Service Manual MC-M570/21/21M/22/37

Transcription

Micro System
MC-M570/21/21M/22/37
Service
Service
Service
Service Manual
COMPACT
TABLE OF CONTENTS
DIGITAL AUDIO
Page
Location of pc boards & Version variations ................ 1-2
Technical Specifications ............................................. 1-3
Measurement setup .................................................... 1-4
Service Aids, Safety Instruction, etc. .......................... 1-5
Disassembly Instructions & Service positions .............. 2
Service Test Programs ............................................... 3-1
Set Block diagram ...................................................... 4-1
Set Wiring diagram ..................................................... 5-1
Front Board .................................................................... 6
ECO6 Tuner Board : Systems Non-Cenelec ............. 7A
Systems Cenelec ..................... 7B
5DTC Module (MP3 Version) ...................................... 10
Power 2003 Module (100W Class D) .......................... 11
Set Mechanical Exploded view & parts list ................. 12
©
Copyright 2003 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
CLASS 1
LASER PRODUCT
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of Philips.
Published by BB 0313 Service Audio
Version 1.0
Printed in The Netherlands
Subject to modification
GB
3139 785 30290
1-3
SPECIFICATIONS
GENERAL:
Mains voltage : 110-127V/220-240V Switchable for /21/21M
Frequency response within -3dB
: 50Hz-16kHz
120V for /37
220V for /33
MAX Sound
: On / Off
Digital Sound Control (DSC) : Jazz / Rock / Pop / Optimal
220-230V for /22
230-240V for /30
Virtual Environment Control (VEC) : Cyber Hall / Concert /
Cinema / Off
Mains frequency
Clock accuracy
: 50/60Hz
: < 4 seconds per day
Input sensitivity
Aux in (at 1kHz) : 500mV at 600 ohm
CDR in (at 1kHz) : 1000mV at 600 ohm
Dimension centre unit : 175 x 268 x 316mm
USB (at 1kHz) : 830mV at 600 ohm
Power consumption
Active
: 80W for /22/33/37
Active
Standby
: 90W for /21/21M
: < 15W (DEMO mode off)
Output sensitivity
Headphone output at 32 ohm : 15mW ± 2dB (Max. vol.)
ECO Power Standby
ECO Power Standby
: < 0.5W for /22/33/37
: < 1W for /21/21M
5DTC:
TUNER:
Measurement done directly at the connector on the board.
Output Resistance
: < 100 ohm
FM
Tuning range
: 0.5Vrms ± 1dB (unloaded)
: < ±1dB
: 87.5-108MHz
Output Voltage (0dB, 1kHz)
Channel Unbalance
Grid
: 50kHz
100kHz for /37
Channel Separation (1kHz) : > 60dB
Frequency Response (±3dB) : 20Hz-20kHz
IF frequency
Aerial input
: 10.7MHz ± 25kHz
: 75 ohm coaxial
Signal to Noise Ratio
MP3-CD Bit Rate
: > 76dBA
: 32-256 kbps
Sampling Frequencies
: 32, 44.1, 48 kHz
300 ohm click fit for /37
: < 7uV
Sensitivity at 26dB S/N
Selectivity at 600kHz bandwidth
Image rejection
: > 25dB
: > 25dB [> 75dB]
USB:
Measurement done directly at the connector on the board.
Distortion at RF=1mV, dev. 75kHz
-3dB Limiting point
: < 3%
: < 8uV
Output Resistance
Output Voltage (0dB, 1kHz)
: < 1.5 kohm
: 830mVrms ± 1.5dB
Crosstalk at RF=1mV, dev. 40kHz
: > 18dB
Channel Unbalance
(RL = 33 kohm)
: < ±1dB
MW
Tuning range
: 531-1602kHz
THD + Noise (0dB, 1kHz)
: < 0.3%
Channel Separation (0dB, 1kHz) : > 40dB
Grid
530-1700kHz for /21/21M/37
: 9kHz
Frequency Response (±3dB)
Signal to Noise Ratio
IF frequency
10kHz for /21/21M/37
: 450kHz ± 1kHz
Aerial input
Sensitivity at 26dB S/N
: Frame aerial
: < 4.4mV/M
Selectivity at 18kHz bandwidth
IF rejection
: > 18dB
: > 45dB
Image rejection
Distortion at RF=50mV, M=80%
: > 28dB
: < 5%
AMPLIFIER:
Output power (6 ohm, 1kHz, 10% THD)
L&R
: 2 x 100W RMS
Output power (6 ohm, 60Hz-12.5kHz, 10% THD)
L&R
: 2 x 95W FTC
/37
[....]
: 20Hz-20kHz
: > 75dBA
Values indicated are for "ECO6 Cenelec Board" only.
2-1
2-1
DISMANTLING INSTRUCTIONS
Dismantling of the 5DTC Module
1) Loosen 4 screws and remove the Cover Top (pos 255) by
sliding it out towards the rear before lifting up.
-
2 screws on the rear
1 screw each on the left & right side
2) Loosen 3 screws each to remove the Panel Left (pos 253)
and Panel Right (pos 254). The Panels are remove by
sliding it towards the rear and outwards.
- 1 screw on the side
- 2 screws on the rear
3) Take a paper clip or any stiff wire diameter of 1mm-1.5mm.
Place the set in position and insert the paper clip or stiff
wire as shown in Figure 1.
4) To remove the Cover CD Orn (pos 111), you have to feel
Figure 3
and give a push in the correct direction (see Figure 1) and
correct position (see Figure 2) to release the catch of the
Cover CD Orn before removing it out.
5) Loosen 4 screws A (see Figure 3 and Figure 9) to remove
the 5DTC Module (pos 1103).
- 2 screws on the front
- 2 screws on the rear
Note : For information on the 'Emergency opening of the
trays' of the 5DTC Module, refer to Chapter 10
(Page 10-7).
Detaching the Front Panel assembly from the Bottom/Rear assembly
1) Remove 2 screws B (pos 282) as shown in Figure 4 from
the bottom of the Cabinet Front (pos 101).
Figure 1
2) Release the fixation of the Combi Board (pos 1102-1001)
to Bracket Combi (pos 252) by releasing the 2 catches C1
(see Figure 5) and pulling the Combi Board outwards as
shown in Figure 6.
3) Uncatch 2 catches C2 (see Figure 5) on the left & right
sides of the Cabinet Front (pos 101) and slides the Front
Panel assembly out towards the front.
Figure 4
Figure 2
Figure 6
Figure 5
2-2
2-2
Dismantling of the Front Panel assembly
Dismantling of the Rear Panel assembly
1) The Knob Volume (pos 136) can be remove by pulling it out
in the direction as shown in Figure 7.
1) Loosen 3 screws H and 2 catches C3 (see Figure 9)
to remove the Tuner Board assembly.
2) Loosen 4 screws D (see Figure 8) to remove the Bracket
Top (pos 251) and CDC Key Board (pos 1105B).
2) Loosen 1 screw K (see Figure 9) to free the Mains
Socket Board (pos 1102-1002B).
3) Loosen 2 screws E (see Figure 8) to remove the Bracket
Combi (pos 252).
3) Loosen 4 screws J and 2 catches C4 (see Figure 9)
to remove the Cabinet Rear (pos 256) by sliding it
4) Loosen 9 screws F (see Figure 8) to remove the Front
Board (pos 1105A).
out towards the rear (see Figuer 10).
Note : Tuner Board assembly and Mains Socket
5) Loosen 3 screws G (see Figure 8) to remove the USB PC
LINK Board (pos 1106).
Board can also be remove together with the
Cabinet Rear.
4) Loosen 4 screws L (see Figure 9) to remove the Fan
(pos 1104) from the Cabinet Rear.
Figure 10
Figure 7
Figure 8
Figure 9
2-3
2-3
Repair Hints & Service Positions
Service position B
1) During repair it is possible to disconnect the ECO6 Tuner
Note: The flex cables are very fragile, care should be taken
board and/or 5DTC Module completely unless the fault is
suspected to be in that area. This will not affect the
not to damage them during repair. After repair, be
very sure that the flex cables are inserted properly
performance of the rest of the set.
into the flex sockets before encasing, otherwise faults
may occurs.
Service position A
Service position C
3-1
3-1
SERVICE TEST PROGRAM
To start service test program
hold ™ & PROG
depressed while
plugging in the mains cord
S refers to Service Mode
Display shows the
ROM version
"S-Vyy"
(Main menu)
V refers to Version
yy refers to Software version number of the uProcessor
(counting up from 01 to 99)
Figure 1
QUARTZ
TEST
TUNER
TEST
TUNER
Button pressed?
N
O
Button pressed?
Y
N
Display shows
32K
Output at (Front Board)
pin 19 of uP = 2048Hz
Service frequencies are
copied to the RAM (see Table 1)
Tuner works normally except:
** Choose
level
by pressing
ERROR
5DTC-Vnn
-
2
MP3CD’02
-
-
Indicates the module used.
**3
TI-Vnn
-
-
Version of the MPEG software (nn = Version Number).
**4
TI BUS
BUS OK
CD
Button pressed?
BUS ER
Communication test between the Main uP and CD Module
R
**5
TI SLD I
-
-
CD SLEDGE MOTOR is moved in.
**6
TI SLD O
-
-
CD SLEDGE MOTOR is moved out.
N
N
R
Y
**7
TI FOC
FOC OK FOC ER
Service Mode left
E1000
87.5MHz
FOCUS SERVO Test.
East Europe
"EAS"
87.5MHz
East Eur. Extended-band
"EAS"
65.81MHz
USA
"USA"
87.5MHz
Oversea
"OSE"
87.5MHz
2
108MHz
108MHz
108MHz
108MHz
108MHz
3
531kHz
531kHz
74MHz
530kHz
531/530kHz*
4
1602kHz
1602kHz
87.5MHz
1700kHz
1602/1700kHz*
5
558kHz
558kHz
531kHz
560kHz
558/560kHz*
6
1494kHz
1494kHz
1602kHz
1500kHz
1494/1500kHz*
7
87.5MHz
87.5MHz
558kHz
98MHz
87.5/98MHz*
8
87.5MHz
87.5MHz
1494kHz
87.5MHz
87.5MHz
9
87.5MHz
87.5MHz
98MHz
87.5MHz
87.5MHz
10
87.5MHz
87.5MHz
70.01MHz
87.5MHz
87.5MHz
11
98MHz
98MHz
65.81MHz
87.5MHz
E1001
E1002
Note: * Depending on the selected grid frequency (9 or 10kHz).
By holding the PROG and R buttons depressed while switching on the Mains supply, one
of the undermentioned features will be activated:
- the tuning grid frequency is toggled between 9kHz and 10kHz for the Oversea (/21) version.
- the extended FM1 (65.81MHz - 74MHz) is toggled on and off for East Eur. (/34) version.
N
Y
DTC works as in normal operation.
In case of failures, error
codes according to Table 2
will be displayed.
Display shows Figure 2
and switch alternate LEDs on
(see Table 3)
Display shows "ADC2 Value"
for ADC 2
(Input Line - Option)
The Service Play Mode is intended
to detect and identify the failures
in the CD Mode.
N
PLAY
Button pressed?
Y
9
Button pressed?
Radial Error
Triggered when the radial servo is off-track for a certain time during playing of CD.
E1005
Jump Error
Triggered in normal play when the jump destination could not be found within a certain time.
E1006
Subcode Error
Triggered when a new subcode was missing for a certain time during playing of CD.
E1007
PLL Error
The Phase Lock Loop could not lock within a certain time.
E1008
Turntable Motor Error
Generated when the CD could not reached 75% of speed during start-up within a certain time. Disc
motor problem.
Focus Search Error
The focus point has not been found within a certain time.
E1061
The tray could not enter the inside position and is opening again. This can happen if the tray is blocked
such that it cannot go fully inside, or if the 5DTC control module is defective and never closes.
The tray could not reach the outside position and is stopped at its blocked position. This can happen if
the tray is blocked such that it cannot go fully outside, or if the 5DTC control module is defective and
never opens.
N
Y
ADC Test is used for checking the
ADC inputs to the microprocessor.
LEDs
MC-M570
MC-500
CD
OFF
-
TUNER
ON
-
AUX
OFF
USB PC LINK
ON
-
MAX SOUND
OFF
OFF
USB Indicator
ON
ON
The display shows an ADC value
between 0 and 255 for an input
signal between 0 and 5V.
Table 3
Various
other Tests
TEST
EEPROM TEST
E1020
N
for ADC 3
(Input Line - AmNtc)
Focus Error
Triggered when the focus cannot be found within a certain time when starting up the CD, or if the focus
is lost for more than a certain time during playing of CD.
Sledge In Error
The sledge did not reach its inner position (inner-switch is still close) before approximately 6 seconds
have passed by. Inner-switch or sledge motor problem.
9
Button pressed?
Y
Error Description
Table 2
VEC
Button pressed?
Y
Display shows "5DTC-Vnn" Version of 5DTC control software
(nn = Version Number).
Sledge Out Error
The sledge did not come out of its inner position (inner-switch is still open) before approximately 250ms
have passed by. Inner-switch or sledge motor problem.
E1079
N
PLAY
Button pressed?
Y
E1003
98/87.5MHz*
Table 1
N
In this mode the DTC works as in
normal operation. The electronics
will still function even when an error
is detected so that repair activities
can be carried out.
Press 9 to exit
Error code
Display shows Figure 1
and switch all LEDs on
(except ECO POWER LED)
5DTC-ER Version of the 5DTC control software (nn = Version Number).
1
Y
1
N
VEC
Button pressed?
Y
for ADC 1
(Input Line - SA)
Set is in Service PLAY Mode
N
Display shows
12M
Output at (Front Board)
pin 19 of uP = 2,929.6875Hz
9
Button pressed?
Europe
"EUR"
N
PLAY
Button pressed?
Y
ACTION
DISPLAY
OKAY
Y
PROGRAM button
PRESET
N
Y
MESSAGE
STEP
N
O
Button pressed?
Disconnect
Mains cord ?
ECO
Button pressed?
Y
DISPLAY
TEST
ADC
TEST
SERVICE PLAY MODE
(For MC-500 only)
Note : Disc should be available on the tray before entering the Service Test Mode.
Display Tuner Version
"ccc"
TUNER
Button pressed?
N
CD
Button pressed?
Y
5DTC CONTROL &
MP3 CD MODULE
TEST
(For MC-M570 only)
Figure 2
Activated with
R
9 to Exit
ACTION
A test pattern will be sent to the EEPROM.
"PASS" is displayed if the uProcessor read back the test pattern
correctly, otherwise "FAIL" will be displayed.
EEPROM FORMAT
TEST
Q
DEMO TOGGLE
MAX SOUND
Pressing this button will toggle between DEMO ON and DEMO
OFF. The DEMO status will scroll once across the Display.
ROTARY
ENCODER TEST
Rotary Volume
Knob
Display shows value for 2 seconds.
Values increases or decreases until Volume Maximum (0dB) or
Volume Minimum (VOL MUTE) is reached.
MICRONAS
FIRMWARE
VERSION
USB PC LINK
To read out the Firmware Version of IC UAC3553 on the USB
PC LINK Board.
Display shows "Vxxxx" (xxxx = Firmware Version number).
LEAVE SERVICE
TEST PROGRAM
9 to Exit
Load default data. Display shows "NEW" for 1 second.
Caution! All presets from the customer will be lost!!
Disconnect
mains cord
Micro 2003_MC-500 & MC-M570_Service Test Program (dd wk0242)
4-1
4-1
SET BLOCK DIAGRAM
+CD +12V_M
-6dB Track
MP3
+12V_A
5DTC
250mV
125mV
M
A
+12V_A
500mV
76dBA
16dB
FM (67.5 kHz)
AM (80% MOD)
ECO6
D
NOTE :
SA BUFFER
MEASUREMENTS ARE IN AUX MODE :
CDC
D
MAIN SIGNAL PATH
CONTROL
XX mV
YY dBA
LEVELS AT MAX VOL
S/N AT 500mW Output
ZZ dB
HEADROOM (1% THD) WRT TO LEVEL AT MAX VOL
TUNER
CONTROL
A
+9.1V
+9V
+9.1V
A
+12V_A
REG
TDA7468
COMBI
SOFTWARE CONTROL
500mV
85dBA
16dB
2.50V
85dBA
3dB
HEADPHONE
AMPLIFIER
+12V_A
INCREDIBLE
SURROUND
AUX / CDR
500mV / 1000mV
TREBLE
VOL. 1
VOL. 2
POWER
AMPLIFIER
NJM4556AM
-8.5dB
SOURCE SELECTOR
39R
1.90V
67dBA
39R
I2C
830mV
AMP_OFF
LEFT/RIGHT
&
BASS
INTERFACE
ATTN.
+AMP -AMP
CLASS D
+12V_A
3.0dB
+5V6
A
+C +12V_A
I2C DATA
I2C CLK
ATTEN.
500mV
USB
HP_OUT
USB
D
A
SIMPLE
IS FILTER
HP_MUTE
HP_DET
Rin = 3k
MUTE
LEFT/RIGHT
+5V6
MUTE_HP
COMBI
D
D
USB
A
CONTROL
CONTROL
AMP_OFF
AMP_MUTE
AMP_RELAY
+5V6
A
M62320FP
I2C DATA
I2C SHIFT
I2C CLK
REGISTER
CD_ON
+5V_CD
L/R SPEAKER
AMP_RELAY
AMP_MUTE
2 X 100W
A
+5V6
2 X 6 OHMS
+C
SOURCE/USB/PC_LINK
NTC
MAX/VEC LEDS
TRAFO
FUSE
ECO POWER
LED
I2C DATA
SHIFT
REGULATOR
+5V6
REGISTER
+F
POWER
CONTROL
L
FUSE
+AMP
I2C CLK
+D
LM317P
MAINS
+D2
FOR -/21 ONLY
CHOKE
N
PWDN
NTC
PWDN
LPC
+12V_A
+C
REGULATOR
LM317P
+D
-AMP
VOLTAGE
+12V_D
RDS
DECODER
-33V
+5V6
-33V
uP
(NOT USED FOR -/37)
SELECTOR
10M
(ONLY FOR -/37)
+5V6_ECO
TUNER
TMP88CU74YF
CONTROL
+C
IR EYE
LOW_POWER_SUPPLY
FUSE
F1x
5DTC
FTD
D
CONTROL
EEPROM
VOLUME
SA IN
USB
CONTROL
CONTROL
+D
F2x
F1
+D2
F2
+D
LOW_POWER_CONTROL
+D
ADC
HP DET
F1x
F1
F2x
F2
FUSE
KEY SCAN
HP_DET
650mV
78dBA
3.2dB
POWER SUPPLY
+5V6_ECO
LPS
SMPS
-33V
HP_OUT
HEADPHONE
FRONT
Block Diagram_3139 119 35800 dd wk0313
5-1
5-1
SET WIRING DIAGRAM
1
FCS 1402
1
FCT 1018
FCT 1012
1
FCS 1824
5DTC
(1103)
8009
9P/180mm/AD
8003
15P/480mm/BD FOLD
FCS 1401
1
1
FCT 1026
8008
19P/180mm/AD FOLD
MP3
FRONT
(1105A)
FAN
EHT 1401
1
2P/260mm
FCS 1301
8007
4P/120mm/AD
1
1
COMBI
(1102-1001)
FCT 1014
(1104)
EHT 1010
1
1302
TO BOTTOM PLATE
HP
1
FCT 1022
## 8101
1P/180 mm
## 8101
FCT 1400
FCT 1011
1
8303
10P/220mm
BI 8100
1
SUPPLY (MAINS)
(1102-1002)
FCT 1013
1
## 1004
1005
CDC KEY
(1105B)
8100
2P/100mm
FCS 1703
## 1006
1307
1
1
DIP 0201
8001
7P/220/mm/AD
AUX-IN
8006
8P/100mm/BD
SUBWOOFER OUT
DIGITAL OUT
LOUDSPEAKER
TRAFO
EHT 1336
PIN TYPE
8004
8P/280mm/AD FOLD
1
8010
1P/180 mm
FCS 1702
8005
7P/220mm/AD
1
FCT 1120
LPS
FROM TUNER’S METAL STRIP
TO AUX’S METAL STRIP
ON REARCAB
1204
N
L
EHS - EH SIDE ENTRY
BI - BOARD IN ENTRY
1
1701
## - PROVISION
USB
FCS - FFC SIDE ENTRY
FCT - FFC TOP ENTRY
FCT 1210
TRAFO
1
LEGEND
EHT - EH TOP ENTRY
(5001)
USB
(1106)
## 8011
1P/100 mm
TO BOTTOM PLATE
ECO6
(1101)
Wiring Diagram_3139 119 35791 dd wk0313
6-1
6-1
FTD DISPLAY PIN CONNECTION
1G
B1
B1
B2
B2
B3
B4
3G
4G
5G
6G
7G
B3
B4
8G
col
Dp
B5
B6
B7
B5
B6
B7
B8
FRONT BOARD
B8
B9
B9
2G
10G
a
f
(2G~9G)
h
r
FTD Display Pin Connection ........................................... 6-1
Front Board - Circuit diagram (Part 3) ............................. 6-6
CDC Key Part - Layout & Circuit diagram ....................... 6-7
Variant Table .................................................................... 6-7
Electrical parts list ............................................................ 6-8
S2
S3
S4
S5
S6
S7
S8
S9
S10
(1G)
m
p
S1
b
n
S6 S5 S4 S3 S2 S1
S1 S2 S3 S4 S5 S6
S7
c
(10G)
S7
d
TABLE OF CONTENTS
k
g
e
Front Board - Component layout ..................................... 6-2
Front Board - Chip layout ................................................ 6-3
j
9G
1G
2G
3G
4G
5G
6G
7G
8G
9G
10G
P1
S1
a
a
a
a
a
a
a
a
S1
P2
S2
h
h
h
h
h
h
h
h
S2
P3
S3
j,p
j,p
j,p
j,p
j,p
j,p
j,p
j,p
S3
P4
S4
k
k
k
k
k
k
k
k
S4
P5
S5
b
b
b
b
b
b
b
b
S5
P6
S6
f
f
f
f
f
f
f
f
S6
P7
S7
m
m
m
m
m
m
m
m
S7
P8
S8
g
g
g
g
g
g
g
g
P9
S9
c
c
c
c
c
c
c
c
P10
S10
e
e
e
e
e
e
e
e
P11
r
r
r
r
r
r
r
r
P12
n
n
n
n
n
n
n
n
P13
d
d
d
d
d
d
d
d
P14
B1
-
-
-
-
col
-
B1
P15
B2
-
-
-
-
Dp
-
B2
P16
B3
-
-
-
-
-
-
B3
P17
B4
-
-
-
-
-
-
B4
P18
B5
-
-
-
-
-
-
B5
P19
B6
-
-
-
-
-
-
B6
P20
B7
-
-
-
-
-
-
B7
P21
B8
-
-
-
-
-
-
B8
P22
B9
-
-
-
-
-
-
B9
P23
-
-
-
-
-
-
-
-
-
6-4
6-4
FRONT BOARD - CIRCUIT DIAGRAM (Part 1)
1
2
3
4
5
Front Board
Circuit Diagram (Part 1)
6
7
8
9
10
Note : DC Voltages During Active Play.
-33V
12
13
1403
BJ897GNK
Values in Bracket are DC Voltages at Standby (Clock Mode).
Values in Square Bracket are DC Voltages at Low Power Standby.
4412
11
46
45
44
43
42
41
V17
V16
V15
V14
V13
V12
V11
V10
V9
V8
V7
V6
V5
V4
V3
V2
V1
V0
AIN4 30
1K
3480
KEY2
AIN3 29
3479
1K
KEY1
AIN2 28
1K
3478
KEY0
AIN1 27
3477
1K
AIN0 26
1K
3476
3475
1K
19
20
21
22
23
24
TUSTEREO
CD_RAB__uP_FRAME
MpOscShiftTu
3459
3460
1K
1K
3461
3462
D
470R
1K
D
# 3546
CD_SICL__uP_DATA
470R
RC6
1K
3471
USB_SUSP
1K
3470
D
D
3473
3472
D
TURdsClk
1K
3469
USB_IIC_DATA
3468
100R
USB_IIC_CLK
100R
3467
USB_READY
3466
100R
USB_IRQ
100R
3465
Standby
D
5405
2p2
2467
4u7 50V
4
5
USB_IRQ
FE-ST-VK-N
10n
G
TURdsDATA
TU
9404
1M
3439
1M
7401
M24C02
1
2
3
USB
ADC
D
9406
ADC
D
3426
6
1K
7
E0
H
8
VCC
+C
E1
E2
SDA
5
3427
IIC_DATA
Reset
1K
SCL
WC_
CD
3421
3422
1K
680K
4.9V
3413
100K
470n
2u2
IIC
D
VSS
4
IIC_CLK
D
7405
BC847B
I
220K
47p
8
10n
2409
2K2
USB_READY
USB_IRQ
2424
3409
D
D
AT-51
D
3139 118 56320...8239 210 94032 for 3501 pt2 dd wk0251
1
2
3
F
+C
7
2423
D
TU
3410
+D
# 9402
9430
220K
6
2422
FTD
D
47p
4410
USB_READY
6K8
9412
9403
11
2408
GND_USB
D
3428
TURdsClk
3416
D
I
5
4.9V
1K
1K
6
4402
PWDN
D
D
100n
3417
VSSA VSSD
13 14
USB_IIC_CLK
1K8
2455
RDDA 2
SIGNAL
QUAL 1
QUALITY
DET
10K
OSCI
D
OSCO
OSC
&
CLK
TEST
9 MODE CTRL
4
USB
10K
3419
15 TCON
USB_IIC_DATA
USB_IIC_CLK
USB_SUSP
USB
6K8
COMP
H
3
4400
5407
3418
560p
RDS/RBDS
DEM
USB_IIC_DATA
D
RDCL 16
VSSA
7 CIN CLOCKED
2
3424
8 SCOUT
D
Reset
NC
USB_SUSP
2440
VDDD
1400
1
USB
# 2465
680K
2K7
3423
TU
D
POW SUPPL VREF 3
&
RESET
SYNC 10
57 Khz
BANDPASS
(8th ORDER)
1K
3425
VDDA
D
1N4148
3437
3420
Options
12
3464
+5V6
+C
3438
2418
100n
2415
5
2412
560p
2410
7403
SAA6581T
D
7404
BC847B
4K7
2471
9457
47n
4 MPX
2411
3463
MpOscShiftTu
33p
1K5
+D
2u2
D
1K
D
4.9V
5406
2u2 50V
G
10K
3407
3408
1n
2421
TUENABLE
22p
2420
10K
2416
E
4411
# 6402
10n
F
1K
9435
+C
47p
TUCLK
470R
470R
32K768
2456
3458
1K8
TRAY_IIC_SDA_CD_SIDA
22p
TUDATA
5404
3403
1K8
47p
3457
D
2445
470R
2n2
2444
TRAY_IRQ
3534
3474
22p
470R
2466
SA
+D
TMP88CU74YF
7400
5403
2419
CD_PORE__uC_RESET
3527
D
Options
4K7
18
GND
3537
17
10K
P4
8-Bit Input/Output
(tri-state)
16
D
OUT
2
CD_SILD__uP_CLK
+D
VS
1
4K7
15
3540
47p
14
3
RC6
100n
13
470R
22p
3526
FTD
# 2479
TRAY_IIC_SCL
D
7301
TSOP4836ZC1
1K
-SCKO 25
D
E
NTC
3536
12
3-B. I/O P3
( tristate )
8-Bit Input/Output
(tri state)
P1
3539
4-Bit In/Output
(tri-state)
P5
1K
2443
11
3481
# 2483
10
VOLA
AIN5 31
4u7
9
VOLB
3482
100n
8
7
1K
1K
5408
6
3483
AIN6 32
4.9V
100R
2413
P07
5
AIN7 33
+C
TURdsDATA
4u7
P06
4
3484
5411
P05
3
1K
C
3538
4.6V [4.6V]
TUCE
# 4401
P04
2
AIN10 34
drain
8-Bit I/O P2
sink o.drain
(-26.9V)
IIC_CLK
47p
P03
1
1K
47p
SO1
80 SI1
10K
3545
10K
# 3544
P0
3485
SCA
sink o.
8-Bit Input/Output
79 -SCK1
AIN11 35
SCL
78 VKK
1K
3486
INT4
1K
3525 1N4148
8-Bit A/D
Converter
-26.5V
F1x
IIC_DATA
1K
INT2
77 V36
CPU
D
3487
TC1
3524
Program
Counter
ROM
B
1
+C
AIN12 36
TC4
6409
RAM
3
+H
AIN13 37
-DV0
76 V35
VFT driver circuit (automatic display)
27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5
VASS 38
80k pull down
TC2
75 V34
80k pull down
P6-P9 source open drain
-INT1
1K
80k pull down
8-Bit high breakdown v.
output port with latch
P6
-INT0
1N4148
8-Bit high breakdown voltage
output port with latch
P7
-STOP
3522
VDD 40 4.9V [4.9V]
38 37 36 35 34 33 32 31 30 29
G10
G9
G8
G7
G6
G5
G4
G3
G2
G1
47
40
P1
P2
P3
P4
P5
P6
P7
P8
P9
P10
P11
P12
P13
P14
P15
P16
P17
P18
P19
P20
P21
P22
P23
3489
1K
1K
1K
G9
G10
3490
3491
G8
1K
1K
G7
G6
1K
3492
3493
1K
G4
3494
3495
G5
1K
1K
G3
1K
3496
3497
G2
P1
G1
3498
1K
P2
1K
3499
P3
3500
1K
P4
1K
3501
P5
3502
1K
P6
1K
3503
48
TEST
6407
50V 22u
2462
2461
P7
3504
1K
49
(tri-state)
50V 22u
P8
1K
3505
50
XTIN
6410
51
-RESET
1K
1N4148
-33V
P9
3506
1K
P10
1K
3507
P11
3508
1K
P12
1K
3509
74 V33
1N4148
52
XTOUT
33K
D
LedEnable
100p
10K
3402
2401
P13
68 V27
73 V32
LedShClk
53
67 V26
72 V31
3523
54
VAREF 39 4.9V [4.9V]
71 V30
6408
55
8-Bit h. break. v.
out w. latch P8
70 V29
LedShData
56
V24
SA_IN
D
57
66 V25
69 V28
LedShStr
58
XIN
1u
59
XOUT
1N4148
60
V18
1K
61
V19
3521
62
F2x
(-26.9V)
V20
3520
63
V21
1K
1K
64
VSS
3404
680K
3519
1K
2406
3406
3405
P23
6401
470K
3518
5-Bit h. breakd. v.
8-Bit h. breakdown v.
out w. latch
PD
out. port w. latch
P9
source open
80k pull
drain 80k p.d.
down
P21
P22
220n
1K
65
SA
2407
3517
1K
V22
P19
C
42
-26.5V
P20
+D
3510
1K
1K
3516
A
2441
P18
1K
3515
3511
P14
1K
1K
P17
V23
B
3514
3512
3513
P15
P16
Note : Some values may varies, see respective parts list for correct value.
Refer to Variant Table.
Legend :
# For Provision Only .
G1
100p
10K
G2
2400
3401
100p
10K
2403
3542
G10
100p
G9
10K
3541
2402
9422
A
4
5
6
7
8
9
10
11
12
13
1400 F13
1403 A10
2400 A5
2401 A5
2402 A3
2403 A4
2406 C2
2407 C1
2408 I1
2409 I2
2410 G1
2411 H1
2412 G3
2413 G12
2415 G2
2416 F1
2418 G5
2419 E6
2420 F6
2421 F7
2422 I11
2423 I12
2424 I12
2440 G11
2441 G11
2443 G12
2444 G12
2445 G13
2455 H8
2456 F7
2461 E3
2462 E3
2465 G11
2466 D11
2467 C12
2471 G3
2479 F6
2483 E12
3401 A4
3402 A5
3403 E9
3404 C2
3405 C1
3406 C2
3407 G1
3408 G1
3409 I2
3410 I1
3413 H12
3416 H3
3417 H3
3418 H3
3419 H3
3420 G7
3421 H11
3422 H12
3423 G7
3424 I12
3425 H7
3426 I7
3427 H9
3428 H9
3437 G8
3438 G8
3439 G9
3457 E4
3458 F4
3459 F4
3460 F4
3461 F4
3462 F4
3463 G5
3464 G8
3465 F9
3466 F9
3467 F9
3468 F9
3469 F9
3470 F9
3471 F9
3472 E9
3473 E9
3474 E8
3475 E9
3476 E9
3477 D9
3478 D9
3479 D9
3480 D9
3481 D9
3482 D9
3483 D9
3484 C9
3485 C9
3486 C9
3487 C9
3489 B8
3490 B8
3491 B8
3492 B8
3493 B8
3494 B7
3495 B7
3496 B7
3497 B7
3498 B7
3499 B7
3500 B7
3501 B6
3502 B6
3503 B6
3504 B6
3505 B6
3506 B6
3507 B6
3508 B5
3509 B5
3510 B5
3511 B5
3512 B5
3513 B4
3514 B4
3515 B4
3516 B4
3517 B3
3518 B4
3519 C3
3520 C4
3521 C3
3522 D4
3523 D3
3524 D4
3525 D3
3526 E4
3527 E4
3534 E9
3536 E12
3537 E12
3538 C12
3539 D11
3540 D11
3541 A3
3542 A4
3544 E4
3545 E4
3546 F5
4400 G8
4401 F11
4402 F11
4410 F11
4411 E12
4412 A5
5403 E6
5404 E6
5405 I2
5406 G1
5407 H7
5408 F12
5411 F11
6401 C1
6402 E11
6407 D4
6408 D3
6409 D4
6410 D3
7301 D12
7400 E8
7401 H8
7403 G1
7404 G6
7405 I12
9402 H6
9403 H5
9404 H6
9406 I6
9412 H5
9422 A4
9430 I5
9435 E12
9457 G3
6-5
6-5
1301 A7
1302 A9
1303 A5
1304 D7
1305 D7
1306 D7
1307 D6
1308 D6
1309 F6
1310 F6
1311 F8
1312 E6
1313 F6
1314 E7
1315 F8
1321 F7
1322 F7
1323 F8
1324 F7
1325 E7
1316 F9
1317 E9
1318 E8
1319 E9
1320 E8
1
1326 D8
1327 D8
1328 F9
1330 E6
2302 B6
2303 B6
2304 B8
2305 B8
2306 B8
2307 E5
2308 F5
2309 D5
2310 D8
2457 D2
2458 D2
2
2459 B4
2460 B4
2469 F4
2470 F3
2473 C1
3307 E2
3308 E2
3309 E2
3310 E2
3311 E3
3300 A1
3301 B1
3304 E1
3305 E1
3306 E1
3
3312 E3
3313 E3
3314 E4
3315 E4
3316 A6
3317 A6
3318 C5
3319 C6
3320 C7
3321 C7
4
3322 C7
3323 D5
3324 D6
3325 D6
3326 D7
3328 C8
3329 D7
3330 D8
3331 D8
3332 D9
3334 F9
3335 E5
3336 F6
3337 F6
3338 F6
5
3339 F7
3340 F7
3341 F7
3342 F8
3343 F8
3529 C2
3530 C2
3531 C3
4403 F3
4404 F4
3344 F8
3345 C6
3346 E3
3347 E4
3528 C1
6
4406 D1
4407 D1
5300 A8
5301 B8
5302 B8
5401 B3
5410 A3
6300 A1
6301 B2
6302 F1
7
6303 F1
6304 F2
6305 F3
6306 E3
6307 E4
7406 A2
7407 B3
7408 F3
7409 F4
8100 C9
8101 B7
9405 B3
8
9
Front Board
VOLB
VOLA
BC857B
7406
HP
1301
+5V6
1
15
1
D
D
10n
2303
2
10n
5
FE-ST-VK-N
D
HP
10K
3530
D
100n
4
1
+C
11
PCLinkLit
3321
3322
3328
390R
560R
820R
1
CDCKEY2
2
100p
AuxLit
3320
270R
1326
12
3319
220R
1327
TunerLit
3345
150R
1304
100p
2458
100p
D
13
KEY2
1305
CDLit
14
1306
D
C
8100
1307
USBLit
1308
7
2K7
MAXLit
100p
6
2309
D
10K
3531
C
3318
5
D
2457
2306
RT-01T 1
2
B
2u2
# 8101
10K
3529
10K
3528
100n
2473
USB
5302
D
STB
3
D
HP_DET
22n
SRG8
EN1
4
100n
2460
16
100n
B
2459
7407
74HC4094D
2u2
4
MT1 MT2
4u7
ADC
5
5301
3 HP_RIGHT
5.6V
5401
9405
+5V6
3
1
2302
6301
47K
3301
4u7
6
3
2u2
2
2305
1303
EC12
[1.7V]
1
22n
5410
1N4148
5300
HP_LEFT
2304
6300
A
4
2
7
2310
[0V]
10K
820R
1302
TC38
3317
+C
+D
10K
A
[1.9V]
3300
+D
Legend :
3316
[4.9V]
35022
D
ADC
D
9
D
D
3325
3326
3329
3330
3331
3332
220R
270R
390R
560R
820R
1K2
1314
1318
1317
1319
1320
1325
1312
100p
820R
3315
820R
2307
USBLit
3314
3313
3324
150R
+5V6
820R
820R
MAXLit
+5V6
3312
2K7
KEY0
1330
D
820R
3311
820R
3310
3323
LedShData
LedShClk
3309
820R
8
+5V6
PCLinkLit
CDLit
3308
820R
820R
3307
820R
3306
TunerLit
LedShStr
LedShClk
LedEnable
4407
820R
3305
820R
AuxLit
+5V6
3304
E
USBLit
LedShData
MAXLit
D
4406
+C
10
E
D
ADC
3337
3338
3339
3340
3341
3342
3343
3344
3334
220R
270R
390R
560R
820R
1K2
1K8
2K7
4K7
1311
1315
1316
PCLINK
3336
150R
1323
KEY1
4404
4403
1321
USB
MAX
1309
3335
6307
3347
10K
1.95V
6306
3346
CD
6305
1328
1324
1322
1313
F
100p
7409
BC847B
7408
BC847B
2308
ADC
ADC
1310
TUNER
6304
6303
6302
AUX
1.95V
10K
1.95V
1.95V
1.95V
2K7
+C
# 2469
# 2470
ADC
22p
ADC
D
22p
3139 118 56320...8239 210 94032 for 3501 pt2 dd wk0251
1
2
3
4
5
6
7
8
9
F
6-6
6-6
1
2
3
4
5
6
7
8
9
Front Board
NON-MP3
1401
IIC_CLK
4
GND_D
5
7
+5V6
8
D
+5V6
3447
10K
3442
10K
3441
10K
39K
10K
1K
3445
3
3543
1K
4
3451
F2
470R
TU_ENABLE
5
2432
6
100p
7
2448
47p
PWDN
8
D
47p
Standby
9
4408
16
uP_CLK
CD_SILD
17
3454
470R
CD_SILD__uP_CLK
470R
3455
CD_RAB__uP_FRAME
3456
470R
CD_PORE__uC_RESET
CD_RAB
18
uC_RESET
CD_PORE
19
FE-ST-VK-N
47p
CD_SICL__uP_DATA
CD_SICL
2436
470R
uP_DATA
47p
3453
15
2435
TRAY_IIC_SDA_CD_SIDA
CD_SIDA
47p
3452
2434
4405
CD
TRAY_IIC_SDA
uP_FRAME
NC
LOW_PWR_CTRL
47p
100n
B
POWER_DOWN
2449
2433
2464
TU_GND
SA_IN
SA_IN
TRAY_IIC_SCL
12
14
TU_CLK
TU_DATA
470R
F1
47K
C
2
TRAY_IRQ
TRAY_IIC_SCL 13
CD_GND
TU_STEREO
3444
1K
TUENABLE
3450
-33V
11
TRAY_IRQ
TUCE
220R
10
F2
TUDATA
1
1K
IIC_CLK
3449
+5V6_ECO
9
-33V
TUCLK
220R
1402
3443
IIC_DATA
3448
6
+5V6
F1
IIC
TUSTEREO
+5V6_ECO
B
IIC
I2C
3440
3
+D
A
3547
IIC_DATA
I2C
10p
2
# 2447
GND_IIC
+C
NTC
9413
10p
1
# 2446
A
NTC
3548
MP3
C
TU
D
470R
FE-ST-VK-N
F1
4u7
+D
# 2474
220p
# 2475
220p
+5V
FTD
100n
2478
2425
100n
100n
+5V6
2463
+5V
1N4003
2437
2438
5409
47u 16V
100n
# 2480
+H
4u7
1N4003
E
6403
5402
47u 16V
6405
2426
3432
10R
+5V6_ECO
50V 4u7
6R8
2427
220R
3429
D
E
3532
F2
D
D
2428
50V 4u7
# 2476
220p
# 2477
220p
10R
22K
100n
2482
100n
# 2481
100n
2468
47u 16V
2439
100n
# 2472
F
+5V
3433
+C
+5V6
3533
2429
6406
50V 4u7
D
3431
D
F2x
6R8
220R
D
1N4003
D
F1x
3430
50V 4u7
10p
2454
10p
2453
10p
10p
2452
2451
D
47p
2450
4409
F
6404
-33V
Legend :
BZX79-B5V6
FTD
FTD
3139 118 56320...8239 210 94032 for 3501 pt2 dd wk0251
1
2
3
4
5
6
7
8
9
1401 A2
1402 A8
2425 E5
2426 D8
2427 E8
2428 E8
2429 F8
2432 B7
2433 C6
2434 C6
2435 C7
2436 C7
2437 E3
2438 E3
2439 F2
2446 A4
2447 A4
2448 B4
2449 B5
2450 D3
2451 D3
2452 D3
2453 D3
2454 D4
2463 E5
2464 C3
2468 F3
2472 F2
2474 D8
2475 E8
2476 E8
2477 F8
2478 E5
2480 E2
2481 F3
2482 F3
3429 D7
3430 D8
3431 F7
3432 D8
3433 F7
3440 A6
3441 A6
3442 A7
3443 A8
3444 B7
3445 B8
3447 A7
3448 B4
3449 B4
3450 B4
3451 B4
3452 C4
3453 C3
3454 C3
3455 C3
3456 D3
3532 E8
3533 F8
3543 B7
3547 A6
3548 C6
4405 C8
4408 C4
4409 D4
5402 E3
5409 E3
6403 E4
6404 F7
6405 E2
6406 F2
9413 A3
6-7
6-7
CDC KEY BOARD - COMPONENT LAYOUT
VARIANT TABLE
Model / Version
This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list.
MC-500/22
MC-500/30
MC-500/25
MC-500/33
MC-M570/33
MC-500/37
MC-M570/37
Item No.
3139 113 3501 pt2 dd wk0251
CDC KEY BOARD - CHIP LAYOUT
This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list.
3139 113 3501 pt2 dd wk0251
3346
10K
10K
3347
10K
10K
3413
100K
3403 / 3534
1K8
1K8
3406
33K
33K
1331 A2
1332 A2
1333 A3
1334 A3
1335 A3
1336 A1
3350 A2
3351 A2
3352 A2
3353 A3
1
2
3
A
3354
4K7
10K
1334
3353
2K7
1333
3352
1K8
1331
EH-B
3351
1K2
1332
2
3350
1335
1336
1
B
D
3139 118 56320...8239 210 94042 for 3501 pt2 dd wk0251
1
2
100K
15K
15K
10K
10K
3419
10K
10K
3423
1K8
1K8
1K8
3437
680K
680K
3438
1M
1M
2M2
2M2
3439
1M
1M
470R
470R
4400
X
X
4403
X
X
4404
X
X
X
X
X
X
3545
10K
3547
39K
10K
4406
X
X
4407
X
X
4408
X
X
6405
X
6407
7408
X
X
7409
X
X
X - Item in use.
B
100K
3354 A3
A
MC-M570/21
3418
3452
CDC KEY BOARD - CIRCUIT DIAGRAM
MC-M570/22
3
6-8
6-8
ELECTRICAL PARTS LIST - FRONT BOARD
MISCELLANEOUS
1301
1302
4822 265 11183
2422 026 05059
Flex Connector 4P
Headphone Socket
2409
2410
4822 126 11785
4822 126 14249
47pF 5% 50V
/22
560pF 10% 50V /22
3312
3313
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3423
3424
4822 116 52249
4822 117 12891
1k8 5% 0,5W
220k 1%
1303
1304
2422 129 16708
4822 276 13775
Rotary Encoder 24P
Tact Switch
2411
2412
4822 126 14249
4822 124 22652
560pF 10% 50V /22
2,2uF 20% 50V /22
3314
3315
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3425
3426
4822 051 30682
4822 051 30102
6k8 5% 0,062W
1k 5% 0,062W
1305
1306
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2413
2415
2238 586 59812
2238 586 59812
100nF 50V
100nF 50V
3316
3317
4822 051 30103
4822 051 30103
10k 5% 0,062W
10k 5% 0,062W
3427
3428
4822 051 30102
4822 051 30682
1k 5% 0,062W
6k8 5% 0,062W
1307
1308
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2416
2418
5322 126 11578
2222 867 15339
1nF 10% 50V
33pF 5% 50V
3318
3319
4822 051 30272
4822 051 30221
2k7 5% 0,062W
220R 5% 0,062W
3429
3430
4822 116 83872
4822 052 10688
!
220R 5% 0,5W
6R8 5% 0,33W
1309
1310
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2419
2420
4822 122 33761
4822 122 33761
22pF 5% 50V
22pF 5% 50V
3320
3321
4822 051 30271
4822 051 30391
270R 5% 0,062W
390R 5% 0,062W
3431
3432
4822 116 83872
4822 052 10109
!
220R 5% 0,5W
10R 5% 0,33W
1311
1312
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2421
2422
4822 126 14223
5322 126 11583
2,2pF 50V
10nF 10% 50V
3322
3323
4822 051 30561
4822 051 30272
560R 5% 0,062W
2k7 5% 0,062W
3433
3438
4822 116 52257
3198 021 32250
22k 5% 0,5W
2M2 5%
1313
1314
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2423
2424
3198 017 44740
5322 126 11583
470nF 10V
10nF 10% 50V
3324
3325
4822 051 30151
4822 051 30221
150R 5% 0,062W
220R 5% 0,062W
3440
3441
4822 051 30103
4822 051 30103
10k 5% 0,062W
10k 5% 0,062W
1315
1316
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2425
2426
4822 124 81286
4822 124 12032
47uF 20% 16V
4,7uF 20% 50V
3326
3328
4822 116 83876
4822 117 12968
270R 5% 0,5W
820R 5% 0,62W
3442
3443
4822 051 30103
4822 051 30102
10k 5% 0,062W
1k 5% 0,062W
1317
1318
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2427
2428
4822 124 12032
4822 124 12032
4,7uF 20% 50V
4,7uF 20% 50V
3329
3330
4822 051 30391
4822 116 52226
390R 5% 0,062W
560R 5% 0,5W
3444
3445
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
1319
1320
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2429
2432
4822 124 12032
2020 552 94427
4,7uF 20% 50V
100pF 5% 50V
3331
3332
4822 116 52231
4822 116 52207
820R 5% 0,5W
1k2 5% 0,5W
3447
3448
4822 051 30103
4822 116 83872
10k 5% 0,062W
220R 5% 0,5W
1321
1322
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2437
2438
2238 586 59812
4822 124 81286
100nF 50V
47uF 20% 16V
3334
3335
4822 116 52283
4822 051 30272
4k7 5% 0,5W
2k7 5% 0,062W
3449
3450
4822 116 83872
4822 051 30471
220R 5% 0,5W
470R 5% 0,062W
1323
1324
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2439
2455
4822 124 81286
2238 586 59812
47uF 20% 16V
100nF 50V
3336
3337
4822 051 30151
4822 051 30221
150R 5% 0,062W
220R 5% 0,062W
3451
3452
4822 051 30471
4822 051 30471
470R 5% 0,062W
470R 5% 0,062W
1325
1326
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2456
2457
4822 122 33761
2020 552 94427
22pF 5% 50V
100pF 5% 50V
3338
3339
4822 116 83876
4822 051 30391
270R 5% 0,5W
390R 5% 0,062W
3453
3454
4822 116 83883
4822 116 83883
470R 5% 0,5W
470R 5% 0,5W
1327
1328
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2458
2459
2020 552 94427
2238 586 59812
100pF 5% 50V
100nF 50V
3340
3341
4822 051 30561
4822 117 12968
560R 5% 0,062W
820R 5% 0,62W
3455
3456
4822 051 30471
4822 051 30471
470R 5% 0,062W
470R 5% 0,062W
1330
1331
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2460
2461
2238 586 59812
3198 028 52290
100nF 50V
22uF 20% 50V
3342
3343
4822 117 11817
4822 117 12903
1k2 1% 1/16W
1k8 1% 0,063W
3457
3458
4822 051 30471
4822 051 30102
470R 5% 0,062W
1k 5% 0,062W
1332
1333
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2462
2463
3198 028 52290
2238 586 59812
22uF 20% 50V
100nF 50V
3344
3345
4822 051 30272
4822 051 30151
2k7 5% 0,062W
150R 5% 0,062W
3459
3460
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
1334
1335
4822 276 13775
4822 276 13775
Tact Switch
Tact Switch
2464
2466
2238 586 59812
4822 126 14238
100nF 50V
2,2nF 50V
3350
3351
4822 117 11817
4822 117 12903
1k2 1% 1/16W
1k8 1% 0,063W
3461
3462
4822 051 30471
4822 051 30102
470R 5% 0,062W
1k 5% 0,062W
1400
1401
4822 265 11535
4822 265 11545
Flex Connector 8P
Flex Connector 19P
2467
2468
4822 124 12032
2238 586 59812
4,7uF 20% 50V
100nF 50V
3352
3353
4822 051 30272
4822 051 30472
2k7 5% 0,062W
4k7 5% 0,062W
3463
3464
4822 051 30472
4822 051 30102
4k7 5% 0,062W
1k 5% 0,062W
1402
1403
4822 265 11531
3139 110 53291
Flex Connector 9P
FTD (BJ897GNK)
2471
2473
3198 017 34730
2238 586 59812
47nF 16V
100nF 50V
3354
3404
4822 051 30103
4822 051 30684
10k 5% 0,062W
680k 5% 0,062W
3465
3466
4822 051 30102
4822 116 52175
1k 5% 0,062W
100R 5% 0,5W
2478
2482
2238 586 59812
2238 586 59812
100nF 50V
100nF 50V
3405
3406
4822 051 30474
4822 051 30153
470k 5% 0,062W
15k 5% 0,062W
3467
3468
4822 116 52175
4822 116 52175
100R 5% 0,5W
100R 5% 0,5W
3407
3408
4822 051 30152
4822 051 30103
1k5 5% 0,062W
10k 5% 0,062W
/22
/22
3469
3470
4822 116 52175
4822 050 11002
100R 5% 0,5W
1k 1% 0,4W
/22
/22
3471
3472
4822 050 11002
4822 051 30102
1k 1% 0,4W
1k 5% 0,062W
4822 051 30471
4822 051 30471
470R 5% 0,062W
470R 5% 0,062W
CAPACITORS
/22
/22
/22
2302
2303
5322 126 11583
5322 126 11583
10nF 10% 50V
10nF 10% 50V
RESISTORS
2304
2305
4822 126 14494
4822 126 14494
22nF 10% 25V
22nF 10% 25V
3300
3301
4822 116 52231
4822 117 12925
820R 5% 0,5W
47k 1% 0,063W
3409
3410
4822 051 30222
4822 117 12891
2k2 5% 0,062W
220k 1%
2306
2307
2238 586 59812
2020 552 94427
100nF 50V
100pF 5% 50V
3304
3305
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3413
3416
4822 117 13632
4822 051 30102
100k 1% 0,62W
1k 5% 0,062W
/22
3473
3474
2308
2309
2020 552 94427
2020 552 94427
100pF 5% 50V
100pF 5% 50V
3306
3307
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3417
3418
4822 051 30102
4822 050 21003
1k 5% 0,062W
10k 1% 0,6W
/22
/21/21M/37
3475
3476
4822 051 30471
4822 051 30102
470R 5% 0,062W
1k 5% 0,062W
2310
2406
2020 552 94427
3198 017 41050
100pF 5% 50V
1uF 10V
3308
3309
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3419
3420
4822 051 30103
4822 051 30272
10k 5% 0,062W
2k7 5% 0,062W
/21/21M/37
3477
3478
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
2407
2408
4822 126 13879
4822 126 11785
220nF +80/-20% 16V
47pF 5% 50V
/22
3310
3311
4822 117 12968
4822 117 12968
820R 5% 0,62W
820R 5% 0,62W
3421
3422
4822 051 30102
4822 051 30684
1k 5% 0,062W
680k 5% 0,062W
3479
3480
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
6-9
RESISTORS
3481
3482
4822 051 30102
4822 050 11002
1k 5% 0,062W
1k 1% 0,4W
3533
3536
4822 052 10109
4822 051 30472
3483
3484
4822 050 11002
4822 051 30102
1k 1% 0,4W
1k 5% 0,062W
3537
3538
4822 051 30472
4822 116 52175
4k7 5% 0,062W
100R 5% 0,5W
3485
3486
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
3539
3540
4822 051 30103
4822 051 30102
10k 5% 0,062W
1k 5% 0,062W
3487
3489
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
3543
4300
4822 051 30102
4822 051 30008
1k 5% 0,062W
0R Jumper 0603
3490
3491
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4301
4302
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3492
3493
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4400
4402
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3494
3495
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4403
4404
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3496
3497
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4410
4411
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3498
3499
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4420
4421
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3500
3501
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4422
4423
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3502
3503
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4424
4425
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3504
3505
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4426
4427
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3506
3507
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4428
4429
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3508
3509
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4430
4431
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3510
3511
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4432
4433
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3512
3513
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4434
4435
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3514
3515
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4436
4437
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3516
3517
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4438
4439
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3518
3519
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4440
4441
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3520
3521
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4442
4443
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3522
3523
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4444
4445
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3524
3525
4822 051 30102
4822 051 30102
1k 5% 0,062W
1k 5% 0,062W
4446
4447
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3526
3527
4822 051 30471
4822 051 30471
470R 5% 0,062W
470R 5% 0,062W
4448
4449
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3528
3529
4822 051 30103
4822 051 30103
10k 5% 0,062W
10k 5% 0,062W
4450
4451
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3530
3531
4822 051 30103
4822 051 30103
10k 5% 0,062W
10k 5% 0,062W
4452
4453
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
3532
4822 052 10688
6R8 5% 0,33W
4454
4822 051 30008
0R Jumper 0603
!
!
10R 5% 0,33W
4k7 5% 0,062W
6-10
RESISTORS
4455
4456
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
7406
7407
4457
4458
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
Note :
4459
4460
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
4461
4462
4822 051 30008
4822 051 30008
0R Jumper 0603
0R Jumper 0603
4822 130 60373
4822 209 15449
Only the parts mentioned in this list are normal
service spare parts.
COILS & FILTERS
5300
5301
3198 018 52280
3198 018 52280
Coil 2,2uH 10%
Coil 2,2uH 10%
5302
5401
3198 018 52280
3198 018 54780
Coil 2,2uH 10%
Coil 4,7uH 10%
5402
5403
3198 018 54780
2422 543 01069
Coil 4,7uH 10%
RES XTL 32,768kHz
5404
5405
5322 242 73686
4822 242 11033
RES CER 12MHz
RES XTL 4,332MHz /22
5406
5407
3198 018 52280
3198 018 52280
Coil 2,2uH 10%
Coil 2,2uH 10%
5408
5409
3198 018 54780
3198 018 54780
Coil 4,7uH 10%
Coil 4,7uH 10%
5410
5411
3198 018 54780
3198 018 54780
Coil 4,7uH 10%
Coil 4,7uH 10%
/22
DIODES
6300
6301
4822 130 30621
9322 179 76676
1N4148
LED VS LTL-816EELC
6302
6303
9322 178 15676
9322 178 15676
LED VS LTL-8166FTNN
LED VS LTL-8166FTNN
6304
6305
9322 178 15676
9322 178 15676
LED VS LTL-8166FTNN
LED VS LTL-8166FTNN
6306
6307
9322 178 15676
9322 178 15676
LED VS LTL-8166FTNN
LED VS LTL-8166FTNN
6401
6403
4822 130 30621
4822 130 31878
1N4148
1N4003G
6404
6405
4822 130 34278
4822 130 31878
BZX79-B6V8
1N4003G
6406
6407
4822 130 31878
4822 130 30621
1N4003G
1N4148
6408
6409
4822 130 30621
4822 130 30621
1N4148
1N4148
6410
4822 130 30621
1N4148
TRANSISTORS & INTEGRATED CIRCUITS
7301
9322 185 97667
IR Receiver TSOP4836ZC1
7400
7401
3139 110 53371
9322 145 26668
TMP88CU74YF - '570S53371'
M24C02-WMN6
7403
7404
9352 686 05118
5322 130 60159
SAA6581T
BC847B
7405
5322 130 60159
BC847B
/22
BC857B
74HC4094D
7A-1
7A-1
BLOCK DIAGRAM
TUNER BOARD
ECO 6 Systems
VStabA
VStabB
FM-IF 1
FM-IF 2
10,7 MHz
10,7 MHz
Vcc1
MPX
buffer ampl.
5
Vdd
Discriminator
FM-RF
RDS
(MPX)
VLoop
1101
(1102)
LF filter
10,7 MHz
Vcc2
VCO
1120
D
A
3
FM
39
37
33
35
18
10
11
4 left
9
1
left 14
43
FM
Mixer
FM
Frontend
FM-Osc.
FM
Osc.
5
VLoop
Prescaler
Multiplexer
AM-Osc.
AM-FRAME AERIAL
1103
AM-RF
2
Stereo
Decoder
Vcc
24
RADIO IC
TEA 5757H
AM IF
AM
Mixer
AM
Frontend
4 right
right 15
stereo
Version
AM
Osc.
6
VLoop
FM
Det.
IF2
IF1
AM
Det.
CONTROL
RDS
(MPX)
enable 29
enable
data 28
data
clock 27
clock
stereo
8
AGC
1
VLoop
VStabA
VStabB
8
P1 31
programmable
output ports
Charge
pump
38
34
AFC
23
7
22
40
41
36
44
32
19
AM-IF 1
AM-IF 2
AM-AFC
450kHz
450kHz
450kHz
VStabA
VStabB
VStabB
3
P0 30
Reference
Oscillator
Stabilizer
AFC +
B
C
AFC -
VLoop
20
25
75kHz
Vdd Vcc1 Vcc2
2
ECO6 Systems, 140499
ECO6 Tuner Board
version: SYSTEMS
non-CENELEC
TABLE OF CONTENTS
Blockdiagram ..................................................................7A-1
Schematic Diagram .........................................................7A-2
Component Layout..........................................................7A-3
Adjustment table .............................................................7A-3
Electrical Partslist ............................................................7A-4
7A-2
2
3
TUNER BOARD ECO6
4
5
6
7
8
9
5111
C-PAD
450kHz
3
4
VERSION
2
7
T115
not USA
2104
/00 /02 FM/MW
100n
/01 FM/MW
AM-IF2
FM-IF1
5112 450kHz
5109
I
1
G
O
3
3
T114
MPX
2n2
to 1120
pin 5
7103
BC857C
3156
100K
100n
3170
PROGR.
OUTPUT PORTS
p
2146
220p
2n2
220p
DATA
6
0V
T120 ENABLE/MPX 5
12Vtyp
(10-14V)
T127
VCC
4
T126
RIGHT
3
1132
T117
11.1V
3154
GND
LEFT
2
1
470R
10.4V
3152
220R
220n
9.5V
2136
3155
470R
9.6V T118
9.6V
T124
3153
7112
BC547C
220n
2
330R
4
H
MPX
BUFFER AMPLIFIER
2134
2
3
4
5
6
7
8
LEGEND
...V
FM mode stereo
p ...for provision only
USA ... for USA version only
E-EU ... for East European version only
J ... for Japanese version only
...V
MW mode
...V
LW mode
V EVM
G
DISCRIMINATOR
ECO6 Sys-non Cenelec, 000911
1
F
FE-BT-VK-N
11.1V
7
7
T121
T125
12V
VDD
CLOCK
0V
C-PAD
2130
VCC2
T122
to/from
120R
120R
0V
2137
11.1V
3167
7.8V
STEREO
E
stereo 0.4V
mono 4.8V
1120
8
15n
22n USA
33p
2149
22n
2124
2169
1K
2135
2119
3144
MPX
from 2169
BZX284-C11
FIELDSTR-IND
2V
7.6V T140 3168
2144
22K
3143
VCC1
VCC2
T123
470R
22
6
8
3158
9.6V
9.5V
6107
2140
2
23
22R
15p
2139
3
stereo
3
VDD
21
mono
mono 4.8V
100n
AFC+
T142 1.1V
VDD
0V
12p
2143
1u
20
2141 T116
AFC-
1V
0V
T141 1.1V
2138
2u2 1.2V
1V
FM-DEMOD
IF-GND
PILOT
FILTER
RIGHT
0.6V
LEFT
0.6V
0.8V
LPF
2132
2K2
3145
470n
2131
T112
19
75KkHz
24 stereo 0.2V
VCC2
470n
4
1.3V
0.7V
H
470n 2133
0.8V
0.15V
7
18
17
2164
15n
22n USA
8
MUTE
330p
2126
6
HN1V02H
16
1n
2167
DT-381
1
33K
1
15
VCC1
3176
2
HN1V02H
3
14
AFC
150K
5121
152kHz, 50mVpp
5V
220n
3146
STEREO
3159
470R
stereo
OSC
MONO/
13
2163
26
25 1.4V
XTAL
AF-OUT
DECODER
2166
220p
VCC2
12
22K
27 0V
5K6
FM
DET
VCO
MPX-IN
3160
3169
DIG-GND
D
3161
28 0V
82p
11
100K
1.4V
FM-IF2
AM-IF2
FM-IF1-IN
CLOCK
AM
DET
AGC
CHARGE
PUMP
1.2V
100K
3157
0.7V 1.1V
1.4V
0.7V
1V
1.4V
VSTABA
FM-MIXOUT
VSTABB
0.1V
29 0V
C
0V
470R
5119
22K
5
30 7.7V
P0
0.2V
7111
BC847C
VSTABB
RDS only
560p
3134
6
4
4
10p
2125
3
P0
WRITE-EN
p
7
47R
2
3132
8
32
1.4V
2148
I-TUNE
8
P1
31 7.9V
DATA
7
1.2V
0.7V
33
P1
VDD
6
18p
MW
5123
2120
6105
6105-2
3
1
6
7P
2145
1K
3181
5
AM-OSCILLATOR
G
1.4V
AGC
VSTABA
VCC1
T110
3
B
RF-GND2
AM-OSC
BAS216
3172
15p
12pE-EU
2p2 J
5130
2153
220n
XH-S
4
56K
1V 9
1.3V
0.7V 10
2127
2159
2
3141
MULTIPLEXER
PRESCALER
6120
P1
1
AM-AFC
AGC
CONTROL
VERSION DETECTION
4
2
34
STEREO
1u
5
2107
6
1 T106
11p
2 T105
1.4V
10u
FM
OSC
FM
MIXER
450kHz
1u
11p
4p7
FM
FRONTEND
FM-OSC
T111
1
HN1V02H 7
7 7KL
1
2106
5102 8
35
36
FM
IF2
AM
IF
AGC
STABILIZER
1.6-8V 8
1-8V
3142
1
2
AM-AFC
5114
3
2161 p
RF-GND1
7.8V
100K
3
FM
IF1
AM
MIXER
AM
OSC
33p
6105-1
MW
AM FRAME AERIAL
B
100n
4
0.1V 5
VCC1 7.6V 7
1SV228
6130
AM-RF
33n
560pE-EU
2152
33K
component mounted
8
22n
1n
FM-RF
RIPPLE
E
37
2
FM-IF2-IN
AM
FRONTEND
3
0V 6
VCO
38
O
CONTROL
p
2154
D
FM-OSCILLATOR
39
40
1
G
CTRL
printed
3101
A
FM-IF2
AGC
AM-RF
printed
2155
6131
100K
7
7P
AM-IF
RIPPLE
0V 2
T128
1SV228
3102
D
2V
1
100u
2103
0V
5131
AM DET
41
AM-MIXOUT
7102
BF550
42
43
AM-IF1-IN
100n
2129
Q-multiplier
0.8V
2165
0.6V
44
FM-IN
7101
TEA5757H
TEA5759H J
AGC
3103
FM-RF
C
7111
/06 FM-Japan/AM
1
I
T109
220R
BAS216
6106
C-PAD
3170
5110
0.2V 2128
3105
3157
/17 FM/AM
2
2
C
1131 T103
3156
/14 FM-OIRT/MW
4
6
3113J
47p
2101
printed
8K2
100n
7119J
BFS20
IF-AMP.
100p
6103
BAV99
6120
2150
1K
T102
2
F
2112J
0R
1
2102
4103
100p
8
T113
3119J
3104
1
6
330R
FM 75 OHM
1103
14
/00 /02 FM/MW/LW
330R
YKD21
B
13
AM-IF1
1
1102
12
/ SYSTEMS NON CENELEC
1130
2 100n
A
11
VERSION PROGRAMMING COMPONENTS
1101USA
USA
3 2105
A
10
2147
1
7A-2
voltages measured while
set is tuned to a strong transmitter
9
10
11
Signal path
FM
AM
MPX (Audio Frequency)
AF - left/right
12
13
14
1101 A1
1102 B1
1103 F2
1120 E14
1130 A2
1131 B2
1132 G13
2101 B3
2102 B1
2103 C7
2104 B3
2105 A2
2106 F3
2107 F4
2119 H6
2120 G6
2124 H6
2125 H6
2126 F7
2127 E7
2128 C8
2129 C7
2130 F11
2131 G8
2132 G8
2133 G8
2134 H8
2135 H9
2136 G14
2137 G13
2138 F9
2139 G9
2140 G9
2141 F10
2143 G12
2144 G11
2145 F12
2146 E12
2147 E12
2148 E12
2149 H7
2150 A10
2152 E4
2153 E5
2154 D5
2155 D5
2159 F6
2161 C11
2163 D11
2164 F10
2165 C7
2166 E11
2167 E11
2169 H8
3101 E4
3102 D4
3103 C6
3104 A7
3105 B6
3132 G5
3134 H6
3141 E7
3142 E7
3143 G7
3144 H7
3145 F8
3146 G13
3152 G14
3153 G13
3154 G13
3155 G11
3156 C12
3157 C12
3158 E13
3159 D13
3160 D12
3161 D13
3167 F12
3168 F11
3169 E11
3170 C12
3172 G12
3176 G7
3181 E6
5102 F2
5109 B9
5110 B10
5111 A8
5112 A11
5114 B11
5119 G9
5121 E11
5123 G5
5130 E5
5131 C6
6103 B2
6105-1 F3
6105-2 G5
6106 C3
6107 G13
6120 C13
6130 E5
6131 D5
7101 C8
7102 C6
7103 H7
7111 C13
7112 G12
T102 B2
T103 B2
T105 F2
T106 F2
T109 B6
T110 F5
T111 F4
T112 F7
T113 A8
T114 B10
T115 A8
T116 F10
T117 G13
T118 G11
T120 F13
T121 F13
T122 F13
T123 E13
T124 G14
T125 F14
T126 F13
T127 F13
T128 D7
T140 F11
T141 F10
T142 F10
7A-3
7A-3
1101 A6 1120 A4 1132 A5 2128 C4 2138 C2 3142 D2 5110 B3 5114 A2 5123 D5 7112 C1 9104 B5 9107 D4
1102 B6 1130 B5 2106 C5 2129 B4 2144 B2 5102 D6 5111 B4 5119 C2 5130 D3 9101 A2 9105 B1 9108 C4
1103 D6 1131 D5 2107 B5 2133 D2 2155 C4 5109 A3 5112 A3 5121 B2 5131 D4 9103 B2 9106 B3 9109 D2
TUNER ADJUSTMENT TABLE ( ECO6 FM/MW- and FM/MW/LW - versions with AM-frame aerial )
Waverange
TUNER BOARD ECO6 Systems non Cenelec / componentside view
Input frequency
Input
Tuned to
Adjust
Output
Scope/Voltmeter
108MHz
5130
8V ±0.2V
check
4.3V ±0.5V
VARICAP ALIGNMENT
A
FM
87.5 - 108MHz
(65.81 - 74, 87.5 - 108MHz)
87.5MHz
MW
1700kHz
5123
8V ±0.2V
530 - 1700kHz
530kHz
check
1.1V ±0.4V
FM/MW-version, 9kHz grid
1602kHz
5123
531 - 1602kHz
531kHz
check
279kHz
5122
8V ±0.2V
153kHz
check
1.1V ±0.4V
1602kHz
5123
8V ±0.2V
531kHz
check
1.1V ±0.4V
(65.81MHz)
FM/AM-version, 10kHz grid
FM 75Ω
LW
153 - 279kHz
MW
FM/MW/LW- version, 9kHz grid
AM FRAME AERIAL
531 - 1602kHz
(1.2V ±0.5V)
6.9V ±0.2V
1
1.1V ±0.4V
FM IF
B
IC 7101
21
10.7MHz, 45mV
continuous wave
D
FM
87.5 - 108MHz
108MHz
A
108MHz
2155
(65.81 - 74, 87.5 - 108MHz)
87.5MHz
87.5MHz
(65.81MHz)
mod=1kHz
∆f=±22.5kHz
5131
98MHz, 1mV
continuous wave
A
98MHz
FM
shortcircuit
to block AFC
2141
5119
2
0 ± 3 mV DC
4
MAX
3
152kHz ±1kHz 1)
FM RF
ECO6 System non Cenelec stage .3, 120900
2130
2131
2132
2134
2135
2136
D5
C5
D6
D7
D7
A4
2137
2139
2140
2141
2143
2145
A4
C6
C6
C6
C7
A5
2146
2147
2148
2149
2150
2152
B7
A5
B6
D6
B5
C5
2153
2154
2159
2161
2163
2164
C5
C4
C5
A6
B6
C6
2165
2166
2167
2169
3101
3102
C4
B6
B6
A4
D5
C3
3103
3104
3105
3113
3119
3132
C4
B4
C4
B5
B5
D5
3134
3141
3143
3144
3145
3146
D3
C5
D6
B7
C5
C7
3152
3153
3154
3155
3156
3157
A4
A4
C7
C7
A6
A6
3158
3159
3160
3161
3167
3168
A4
A5
A5
A5
B7
C7
3169
3170
3172
3176
3181
4103
B6
A6
C7
D6
D4
B5
4106
4107
4108
6103
6105
6106
C4
C5
C5
B3
C3
C3
6107
6120
6130
6131
7101
7102
C7 7103 D7
A6 7111 A5
D4 7119 B5
C4
C5
D4
VCO
FM
TUNER BOARD ECO6 Systems - non Cenelec / copperside view
4
1
3142
AM IF
3
IC 7101 36
C
7
2
(65.81MHz)
8
K
A
MW
A
C
C
41..
(not all items shown
in schematic diagram)
2
(as low as
possible)
5111
5
IC 7101 40
see
remark 2)
100nF
5112
fo
symmetric
5114
continuous wave
2
0 ± 2 mV DC
VRF = 2mV
AM RF 3)
MW 4)
1494kHz
2106
558kHz
558kHz
5102
LW
198kHz
198kHz
5103
MW
1500kHz
1500kHz
2106
560kHz
5102
FM/MW/LW- and FM/MW-version
( 9kHz grid)
531 - 1602kHz
1494kHz
FM/AM-version, 10kHz grid
530 - 1700kHz
Vcc1
∆f=±10kHz
VRF = 0.5mV
C
B E
SMD jumper
Vcc2
connect pin 6 of
IC 7101 (AM Osc.)
with 3.3kΩ to Vcc
MW
Vdd
1
AM AFC
450kHz
100nF
max.
D3
D3
D3
D3
D6
C5
560kHz
B
∆f = ±30kHz
VRF as low as
possible
max.
2119
2120
2124
2125
2126
2127
220R
B4
B1
D4
B4
C1
B5
220R
2101
2102
2103
2104
2105
2112
5
fo
symmetric
ECO6, Sys + PA with frame aerial, 070799
Use Service Testprogram. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically.
D
5
ECO6 Systems non CENELEC stage .3, 120900
1) If sensitivity of frequency counter is too low adjust to max. channel separation
2) RC network serves for damping the IF-filter while adjusting the other one.
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
3) For AM RF adjustments the original frame antenna has to be used !
These assembly drawings show a summary of all possible versions.
For components used in a specific version see schematic diagram respectively partslist.
Repeat
4) MW has to be aligned before LW.
Electrical Partslist ECO6 SYSTEMS NON-CENELEC
MISCELLANEOUS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1101
2422 015 19376 SOCKET 2P CLICKFIT
USA only
1102
4822 267 10283 SOCKET COAX, IEC 75Ω
not USA
1103
4822 265 31184 JST CONNECTOR 2 POLE
1120
4822 265 11515 FFC SOCKET, 8P
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2101 © 4822 126 13692
47pF
1%
63V
2102 © 4822 126 13838
100nF 10%
50V
not USA
2103 © 5322 122 31647
1nF 10%
63V
2104 © 5322 122 32531
100pF
5%
50V
2105 © 4822 126 13838
100nF 10%
50V
USA only
2106
2107
2120 ©
2124 ©
2125 ©
2020 800 00191
4822 121 51319
4822 126 13689
5322 122 32654
2020 552 96199
3-11pF TRIMCAP.,N450
1µF 20%
50V
18pF
1%
63V
22nF 10%
63V
560pF
1%
50V
2126 ©
2127 ©
2128
2129
2130 ©
5322 122 31863
4822 126 14076
4822 124 40248
4822 124 41584
5322 122 32654
330pF
220nF
10µF
100µF
22nF
5%
20%
20%
20%
10%
50V
25V
63V
10V
63V
2131 ©
2132 ©
2133
2134 ©
2134 ©
4822 126 13482
4822 126 13482
4822 124 21913
4822 126 13188
5322 122 32654
470nF
470nF
1µF
15nF
22nF
20%
20%
20%
5%
10%
16V
16V
63V
63V
63V
2135 ©
2135 ©
2136 ©
2137 ©
2138
4822 126 13188
5322 122 32654
4822 126 14076
4822 126 14076
4822 124 22652
15nF
22nF
220nF
220nF
2,2µF
5%
10%
20%
20%
20%
63V
63V
25V
25V
50V
2139 ©
2140 ©
2141 ©
2143 ©
2144
4822 126 14236
4822 126 13695
4822 126 13838
4822 126 14076
4822 124 21913
15pF
82pF
100nF
220nF
1µF
5%
1%
10%
20%
20%
50V
63V
50V
25V
63V
2145 ©
2146 ©
2147 ©
2148 ©
2149 ©
4822 122 33575
4822 122 33575
4822 122 33575
4822 122 33127
5322 122 32659
220pF
220pF
220pF
2,2nF
33pF
5%
5%
5%
10%
5%
50V
50V
50V
63V
50V
2150 ©
2152 ©
2152 ©
2153 ©
2153 ©
4822 126 13838
4822 126 12105
5322 116 80853
4822 126 13486
4822 122 33926
100nF
33nF
560pF
15pF
12pF
10%
5%
5%
2%
2%
50V
63V not for East Europe
63V for East Europe only
63V not for East Europe
50V for East Europe only
2155
2159 ©
2164 ©
2165 ©
2166 ©
2020 800 00191
5322 122 32659
4822 126 13482
4822 126 13838
5322 122 31647
3-11pF TRIMCAP.,N450
33pF
5%
50V
470nF 20%
16V
100nF 10%
50V
1nF 10%
63V
2167 © 4822 122 33926
2169 © 4822 122 33127
12pF
2,2nF
5%
10%
50V
63V
not USA
4822 051 20479
4822 051 20223
4822 117 11148
4822 100 12159
47Ω
5%
0,1W
22kΩ
5%
0,1W
56kΩ
1%
0,1W
TRIMPOT. 100kΩ
7A-4
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3143 © 4822 051 20223
22kΩ
5%
0,1W
RDS only
3144 © 4822 051 10102
1kΩ
2% 0,25W
RDS only
3145© 4822 117 11449
2,2kΩ
1%
0,1W
3146 © 4822 051 20229
22Ω
5%
0,1W
3152 © 4822 051 20471
470Ω
5%
0,1W
3153 ©
3154 ©
3155 ©
3156 ©
3157 ©
4822 051 20471
4822 117 13577
4822 117 11503
4822 117 10837
4822 117 10837
470Ω
330Ω
220Ω
100kΩ
100kΩ
5%
1%
5%
1%
1%
0,1W
0,1W
0,1W
0,1W
0,1W
3158 ©
3159 ©
3160 ©
3161 ©
3167 ©
4822 051 20471
4822 051 20471
4822 051 20471
4822 051 20223
4822 051 20121
470Ω
470Ω
470Ω
22kΩ
120Ω
5%
5%
5%
5%
5%
0,1W
0,1W
0,1W
0,1W
0,1W
3168 ©
3169 ©
3170 ©
3172 ©
3176 ©
4822 051 20121
4822 051 20154
4822 117 10837
4822 051 20562
4822 051 20333
120Ω
150kΩ
100kΩ
5,6kΩ
33kΩ
5%
5%
1%
5%
5%
0,1W
0,1W
0,1W
0,1W
0,1W
3181 ©
4103 ©
4106 ©
4107 ©
4108 ©
4822 051 10102
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
1kΩ
2% 0,25W
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
RDS only
USA only
not USA
USA only
RDS only
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
5102
4822 157 71634 RF-COIL MW
5109
4822 242 70665 FM-IF FILTER 10,7MHz
5110
4822 242 70665 FM-IF FILTER 10,7MHz
5111
2422 549 44023 AM-IF FILTER 450kHz
5112
4822 157 70302 AM-IF FILTER 450kHz
5114
5119
5121
5123
5130
4822 157 70302
4822 157 11443
4822 242 10261
2422 549 44108
4822 157 11843
AM-IF FILTER 450kHz
DISCRIMINATOR COIL
QUARTZ 75kHz
RF-COIL, AM-OSCILLATOR
RF COIL 1,5 TURNS
5131
4822 157 11843
RF COIL 1,5 TURNS
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6103 © 5322 130 34337 BAV99
6105 © 4822 130 83075 HN1V02H
6106 © 4822 130 83757 BAS216
6107 © 9340 386 90115 BZX284-C11
6120 © 4822 130 83757 BAS216
6130 © 4822 130 82833
6131 © 4822 130 82833
RDS only
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3101 © 4822 051 20333
33kΩ
5%
0,1W
3102 © 4822 117 10837
100kΩ
1%
0,1W
3103 © 4822 051 20822
8,2kΩ
5%
0,1W
3104 © 4822 117 13577
330Ω
1%
0,1W
3105 © 4822 117 11503
220Ω
5%
0,1W
3132 ©
3134 ©
3141 ©
3142
7A-4
1SV228
1SV228
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7102
4822 130 42131 BF550
7103 © 5322 130 42756 BC857C
RDS only
7111 © 5322 130 42755 BC847C
7112
4822 130 44503 BC547C
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7101 © 9351 740 80557 TEA5757H/V1, RADIO IC
B
AM-FRAME AERIAL
1103
FM
1101
(1102)
GND
2 3 4
1
Ant.
+FM
6
VCC
FM FRONTEND
5
VLoop
Vvaricap
VLoop
MIXER
TABLE OF CONTENTS
A
Blockdiagram ..................................................................7B-1
Schematic Diagram .........................................................7B-2
Component Layout..........................................................7B-3
Adjustment table .............................................................7B-3
Electrical Partslist ............................................................7B-4
TUNER BOARD
ECO 6 Systems Cenelec
VLoop
C
VStabB
VStabA
VLoop
AM-RF
AM-Osc.
Osc.
out
8
IF
out
7
1
34
38
8
2
6
D
7
22
AM
Mixer
AM
Osc.
Prescaler
Vdd Vcc1 Vcc2
23
Stabilizer
Charge
pump
AM
Frontend
5 FM Osc.
SYSTEMS CENELEC
37
IF1
35
36
VStabB
VStabA
AM-IF 2
450kHz
41
450kHz
AM-IF 1
40
AM IF
AGC
Multiplexer
10,7 MHz
33
IF2
44
AM
Det.
2
AFC
FM
Det.
18
10,7 MHz
19
VStabB
450kHz
AM-AFC
32
5
20
10
Discriminator
RADIO IC
TEA 5762
FM-IF 2
FM-IF 1
10,7 MHz
VStabB
VStabA
AFC -
version:
11
LF filter
MPX
buffer ampl.
Version
25
Reference
Oscillator
75kHz
programmable
output ports
CONTROL
P0 30
P1 31
MW/LW
clock
8
1
1120
ECO6 Systems Cenelec, 140499
AM-RF,
AM-Osc.
3
stereo
data
data 28
enable
clock 27
enable 29
RDS
(MPX)
stereo
24
right
Vcc
right 15
left
Stereo
Decoder
4
4
39
left 14
AM/FM
+FM
Vdd
Vcc2
Vcc1
9
VCO
RDS
(MPX)
AM/FM
ECO6 Tuner Board
AFC +
7B-1
7B-1
BLOCK DIAGRAM
7B-2
2
1
3
7B-2
4
5
6
7
8
9
10
11
12
13
14
VERSION PROGRAMMING COMPONENTS
1.4V
100K
3156
3157
2163 LW
3167
120R
120R
RIGHT
3154
2
LEFT
1
FE-BT-VK-N
330R
DISCRIMINATOR
8.9V
+FM
4
3153
470R
3152
470R
220n
2136
220n
G
2162
8.9V
7
T124
2137
6107
BZX284-C11
22R
150R
8.3V
7.5V
3146
3171
3155
220n
T118
8.2V
47K
2143
9.6V
7112
BC547C
VDD
5K6
3172
12V
2
6
MPX
BUFFER AMPLIFIER
C-PAD
T117
11V
F
3
T125 GND
3151
22u
2139
1
7
to/from
2146
2148
T140 3168
8.2V
8.2V
8
0V T121 DATA
1132
VCC2
7.8V
STEREO
0V T122 CLOCK
H
8.2V
0.7V 3137
P0
3150
0.1V 22K
MW=HIGH
820R
10n
2124 *
100K
2161 p
100n
100n
2145
FIELDSTR-IND
2V
AFC+
1.1V
1.1V
T142
VCC1
E
stereo 0.4V
mono 4.8V
1120
6
0V T120 ENABLE/MPX
5
T127
12Vtyp
VCC
(10-14V) T126
4
from
2169 MPX
22
3
2
3130
7
390p
1
3n3
6
T123
3158
470R
VDD
2141 T116
AFC-
FM-DEMOD
1V
0V
8.2V
8.3V
7.5V
VCC2
21
stereo
mono 4.8V
23
VDD
mono
3
68K
2149
stereo
12p
0V
7124
BC847C
0V
24 stereo 0.2V
22K
3134
560p
2125
IF-GND
FILTER
1.2V
PILOT
1V
0.6V
4
MPX
2n2 to 1120
pin 5
8
p
1n
2167
7110
BC857B
0.7V
150K
5121
DT-381 75 kHz
470R
10K
2118 p
18p
22p LW
2p2
1K
BC857C
7103
33K
20
PROGRAMMABLE
OUTPUT PORTS
VSTABB
FM-IF2
AM-IF2
FM-IF1-IN
VSTABA
AM|FM
0.7V 1.1V
1.4V
0.7V
9V
1.4V
0.4V
1.4V
1.4V
AM-IF1-IN
RF-GND2
MUTE
0.8V
LPF
3143
6105-2 3
5
HN1V02H 6
2169
3144
3
2
8
10p
47R
2119
10K
26
25 1.4V
5119
1.3V
3176
19
152kHz, 50mVpp
5V
2166
LW
5122
4
7.4V 2K2 0.7V
3180
7
2123
LW=HIGH
2120
1
0R
10K
8V
6.7V
470R
3159
VCC2
RDS only
3
2
4104 *
P01
3125
MW
5123
4
6
8.3V
7.5V
BC857B
7122
7109
BC847C 0V
0V
0V 3128 0V
27 0V
D
2164
5118
4K7
P0
18
7111
BC847C
22K
3160
470n
VCC1
VDD
4K7
3123
P0
BIRDY FILTER
17
T141
5
1
16
1nH
6
4
2
15
0V
3161
15p
3
3
14
P0
28 0V
82p
7
13
2u2
2
12
2138
8
AFC
1u
1
8
H
7
2122
VDD
6
8
AM-OSCILLATOR
3132
100p
MW=HIGH
G
7
0.1V
29 0V
OSC
STEREO
DECODER
HN1V02H
0.7V
0.1V
3109
8
2108
1
6
11 MPX-IN
1K 1.2V
0.8V
0.15V
0R
4102
2
10p
2109
4
5115
T112
5
7105
BC337-40
3
WRITE-EN
MONO/
470n 2133 2K2
4
LW only
3135
220n
6105
LW
VCC2
RIGHT
2127
1
7KL
5103
30 7.5V
STEREO
*
B
P0
DIG-GND
1u
2107
100K
3
F
56K
32
1.4V
31 7.5V
XTAL
C
0.2V
1u
3141
T111
P1
P1
DATA
6120
P1
BAS216
3169
FM
DET
8
1.2V
0.7V
FM-IF2-IN 33
AM
DET
CHARGE
PUMP
7
7P
CLOCK
AGC
VERSION DETECTION
6
1
34
AM-AFC
VSTABB
5114 450kHz
4
2
FM
IF2
AM
IF
B
component mounted
AM-AFC
3
FM
IF1
AGC
STABILIZER
3145
4
2
35
AGC
470n
2
G
3
VDD
2132
5
36
MULTIPLEXER
VSTABA
1V 9 VCO
1.3V
0.7V 10 AF-OUT
2131
0R
1
XH-S
PRESCALER
I-TUNE
1.6-8V 8
1-8V
3142
33p
1
O
22n
33p
2159
6
37
AGC
CONTROL
LEFT
2180
6106
4101 *
38
AM
MIXER
AM
OSC
7.8V 7 VCC1
8.2V
VCC1
VCO
11p
20p_LW
T106
MW
7
2106
5102 8
39
0V 6 AM-OSC
HN1V02H
T105
40
4 RF-GND1
MW/LW-RF
1 6105-1 2
7
1
CONTROL
T109
T110
P01 LW =HIGH
2
2
I
CTRL
3 FM-GND
RIPPLE
AM FRAME AERIAL
41
AM
FRONTEND
0.1V 5 FM-OSC
7104
BC337-40
E
G
3
220R
BAS216
0V
42
AM-IF
0V 2 AM-RF
C
LW only
O
AGC
100u
100n
100u
p
2190
100R
2V
1 RIPPLE
43
AM-MIXOUT
2K2
3105
1103
AM DET
100n
2129
+FM
3108 0V
2K2 0.7V
44
2165
3194
3195
D
0.2V
3192
3193
10
T107
2191
7101
TEA5762
0.6V
9
D
820R
3131
7.2V
C
5
1
AM/FM
NC
6
4
I
/17 FM/AM
8
7
7P
5110
2128
AGC
3
120R
10u
A
6
FM-IF2
5109
22K
2
C-PAD
Vvaricap
VCC
GND
0.1V
OSC.
OUT
1.6-8V
100n
8
1131 T103
3191
120R
330R
ANT
YKD31- 2
0432
2102
IF-OUT
330R
MIXER
T104
3190
0V
7
10n
B
0V 1
7111
/14 FM-OIRT/MW
1
FE450
FM-IF1
T102
1
3170
/01 FM/MW
2
220p
FM FRONTEND
1110
1102
11V
FM 75 OHM
T114
2140
A
450kHz
4
3
T115
YKD21
3157
/00 /02 FM/MW
AM-IF2
5112
100n
7
3170
C-PAD
1
2150
1
8
100K
6
1130
2130
100n
2
3156
/00 /02 FM/MW/LW
T113
220p
2
2105 USA
100n
3
6120
3
2n2
450kHz
2147
A
1101USA
VERSION
AM-IF1
5111
4
220p
/ SYSTEMS-CENELEC
2144
TUNER BOARD ECO6
AM/FM
from 7101/39
I
15n
22nUSA
2134
15n
22nUSA
2135
I
marked components not for LW version
ECO6 Sys-Cenelec, 010517
1
2
3
4
5
6
7
8
9
10
LEGEND
* ... only assembled in FM/AM-version
p ...for provision only
USA ... for USA version only
LW ... for LW version only
...V
FM mode stereo
...V
MW mode
...V
LW mode
11
12
Signal path
SMD jumper
41xx
0R
V EVM
voltages measured while
set is tuned to a strong transmitter
FM
AM
MPX (Audio Frequency)
AF - left/right
13
14
1101
1102
1103
1110
1120
1130
1131
1132
2102
2105
2106
2107
2108
2109
2118
2119
2120
2122
2123
2124
2125
2127
2128
2129
2130
2131
2132
2133
2134
2135
2136
2137
2138
2139
2140
2141
2143
2144
2145
2146
2147
2148
2149
2150
2159
2161
2162
2163
2164
2165
2166
2167
2169
2180
2190
2191
3105
3108
3109
3123
3125
3128
3130
3131
3132
3134
3135
3137
3141
3142
3143
3144
3145
3146
3150
3151
3152
3153
3154
3155
3156
3157
3158
3159
3160
3161
3167
3168
3169
3170
3171
3172
3176
3180
3190
3191
3192
3193
3194
3195
4101
4102
4104
5102
5103
5109
5110
5111
5112
5114
5115
5118
5119
A2
B1
E2
B2
E14
A2
C2
F13
B1
A2
E3
E4
G3
G3
H6
H6
H6
I6
H6
H6
H6
E7
B8
C7
F11
F8
F8
F8
I8
I9
H14
H13
F9
G9
G9
F10
G12
G11
E11
E12
E12
E12
H7
A10
D5
C11
H12
D11
G10
C7
E11
E11
G8
C4
C3
C3
D5
D2
G4
H3
H2
H3
I9
I9
G4
H6
E7
H7
E7
E6
G7
G8
F8
G13
H12
H12
G14
G13
F13
G12
C12
D12
E13
D13
D13
D13
F12
F11
E11
D12
G12
G12
H7
I3
B6
B7
B6
B4
C4
C3
E2
F3
H5
E3
F2
B9
B10
A9
A11
B11
E7
G9
G9
5121 E11
5122 H5
5123 G5
6105-1 E4
6105-2 G6
6106 D4
6107 G13
6120 C13
7101 C8
7103 H8
7104 D2
7105 F4
7109 H3
7110 H12
7111 C13
7112 G12
7122 H4
7124 H7
T102 B2
T103 B2
T104 B6
T105 E2
T106 E2
T107 C3
T109 D5
T110 D5
T111 E5
T112 F7
T113 A9
T114 B11
T116 F10
T117 F13
T118 G11
T120 F13
T121 F13
T122 E13
T123 E13
T124 G14
T125 F14
T126 F13
T127 F13
T140 F11
T141 F10
T142 F10
7B-3
1101 B5
1102 B5
1103 C5
1110 B4
1120 A4
1130 A5
1131 C5
1132 A4
2106 B4
2107 B3
2128 A3
2129 B3
2133 C1
2138 B1
2144 B1
2162 A4
2191 B4
3142 C2
5102 C4
5103 C4
5109 B3
5110 A2
5111 A3
5112 A2
7B-3
5114 A2
5115 C2
5119 B2
5121 B2
5122 C3
5123 C3
7104 C4
7105 C5
7112 B1
9101 A2
9102 B2
9103 A1
9104 B1
9105 B1
9106 B1
9107 B4
9108 B3
9109 C2
9110 A4
9111 A3
TUNER ADJUSTMENT TABLE ( ECO6 Cenelec FM/MW - and FM/MW/LW - versions with AM-frame aerial )
Waverange
TUNER BOARD ECO6 Systems - Cenelec / componentside view
Input frequency
Input
Tuned to
Adjust
Output
Scope/Voltmeter
108MHz
check
8V ±1.2V
87.5MHz
check
1.6V ±0.5V
MW
531 - 1602kHz
(9kHz grid)
1602kHz
5123
531kHz
check
1.1V ±0.4V
LW
153 - 279kHz
(3kHz grid)
279kHz
5122
8V ±0.2V
153kHz
check
1.1V ±0.4V
VARICAP ALIGNMENT
FM
87.5 - 108MHz
(50kHz grid)
FM FRONTEND
A
FM 75Ω
1
8V ±0.2V
6.9V ±0.2V
3-band
2-band
FM - IF
FM
AM FRAME AERIAL
IC 7101
10.7MHz, 45mV
continuous wave
D
98MHz, 1mV
continuous wave
A
21
shortcircuit
to block AFC
2141
5119
2
0mV ±3mV
3142
3
152kHz ±1kHz 1)
FM - VCO
B
Birdy Filter
FM
98MHz
ECO6 Sys-Cenelec, layout stage .6, 160501
Note: The FM-frontend unit has already been adjusted by the factory
and needs therefore no further adjustments for service purposes.
FM RF (channel separation)
2137
2139
2140
2141
2143
2145
A3
B4
B4
B5
B5
B5
2146
2147
2148
2149
2150
2159
B5
A5
B4
C4
B3
B3
2161
2163
2164
2165
2166
2167
A4
A4
B4
B3
B5
B4
2169
2180
2190
3105
3108
3109
A3
B2
B2
B3
C2
C1
3123
3125
3128
3130
3131
3132
A5
A5
C2
C4
C4
B3
3134
3135
3137
3141
3143
3144
C3
C4
C4
B3
C5
A5
3145
3146
3150
3151
3152
3153
C4
B5
B3
A2
A3
A3
3154
3155
3156
3157
3158
3159
B5
B5
A4
A4
A3
A3
3160
3161
3167
3168
3169
3170
A3
A4
A5
C5
B4
A4
3171
3172
3176
3180
3190
3191
B5
B5
C4
A5
B2
A3
3192
3193
3194
3195
4101
4102
A2
B2
B2
B2
C2
C2
4104
4105
4106
4107
5118
6105
C3
B2
B3
C4
C4
B2
6106
6107
6120
7101
7103
7109
B2
B5
A4
B4
C5
A5
7110
7111
7122
7124
1
FM
98MHz
C
450kHz
MW
8
A
K
1
+FM
A
D
C
AM AFC
MW
4
right channel min.
5111
5
IC 7101 40
see
remark 2)
100nF
C
5112
5114
continuous wave
fo
symmetric
2
0mV ±2mV
3)
B E
1494kHz
SMD jumper
41..
5118
8
connect pin 6 of
IC 7101 (AM Osc.)
with 3.3kΩ to Vcc
∆f = ±10kHz
VRF = 0.5mV
(as low as
possible)
100nF
VRF = 2mV
AM RF
Vdd
C
A
IF coil
inside
FM frontend
1110
IC 7101 36
3
7
2
98MHz, 1mV
90% Left + 9% pilot
mod=1kHz
AM IF
TUNER BOARD ECO6 Systems - Cenelec / copperside view
4
B2
A4
C3
C3
max.
B3
C4
C4
C5
C5
A3
MW
(not all items shown
in schematic diagram)
B
558kHz
Vcc2
LW
198kHz
Vcc1
∆f = ±30kHz
VRF as low as
possible
1494kHz
2106
558kHz
5102
198kHz
5103
max.
2130
2131
2132
2134
2135
2136
220R
C3
C3
C3
C3
C3
C4
220R
2120
2122
2123
2124
2125
2127
3135
B1
B1
C1
C1
C3
C3
2180
2102
2105
2108
2109
2118
2119
5
fo
symmetric
ECO6 Sys Cenelec, 190599
Use Service Testprogram. By selecting the TUNER TEST test frequencies will be stored as preset frequencies automatically.
1) If sensitivity of frequency counter is too low adjust to max. channel separation
1
5
2
ECO6 Sys-Cenelec, layout stage .6, 160501
(input signal: stereo left 90% + 9%, adjust output on right channel to minimum)
2) RC network serves for damping the IF-filter while adjusting the other one.
3) For AM RF adjustments the original frame antenna has to be used!
MW has to be aligned before LW.
These assembly drawings show a summary of all possible versions.
For components used in a specific version see schematic diagram respectively partslist.
Repeat
7B-4
Electrical Partslist ECO6 SYSTEMS-CENELEC
7B-4
MISCELLANEOUS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1101
2422 015 19376 SOCKET CLICKFIT 2P
USA only
1102
4822 267 10283 SOCKET COAX, IEC 75Ω
not USA
1103
4822 265 31184 JST CONNECTOR, 2 POLE
1110
2422 542 90071 FM FRONTEND
1120
4822 265 11515 FFC SOCKET, 8P
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3128 © 4822 117 11449
2,2kΩ
1%
0,1W
LW only
3130 © 3198 021 38210
820Ω
5% 0,06W
3131 © 3198 021 38210
820Ω
5% 0,06W
3132 © 4822 051 20479
47Ω
5%
0,1W
3134 © 4822 051 20223
22kΩ
5%
0,1W
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2102 © 4822 126 13838
100nF 10%
50V
not USA
2105 © 4822 126 13838
100nF 10%
50V
USA only
2106
2020 800 00204 TRIMCAP. 4,2 - 20pF, N750
LW only
2106
2020 800 00191 TRIMCAP. 3 - 11pF, N450
FM/AM only
2107
4822 121 51319
1µF 20%
50V
3135 ©
3137 ©
3141 ©
3142
3143 ©
3198 021 31020
4822 051 20223
4822 117 11148
4822 100 12159
4822 051 20223
3144 ©
3145 ©
3146 ©
3150 ©
3151 ©
4822 051 10102
4822 117 11449
4822 051 20229
4822 117 10833
4822 051 20683
1kΩ
2,2kΩ
22Ω
10kΩ
68kΩ
2%
1%
5%
1%
5%
0,25W
0,1W
0,1W
0,1W
0,1W
3152 ©
3153 ©
3154 ©
3155 ©
3156 ©
4822 051 20471
4822 051 20471
4822 117 13577
4822 117 10353
4822 117 10837
470Ω
470Ω
330Ω
150Ω
100kΩ
5%
5%
1%
5%
1%
0,1W
0,1W
0,1W
0,1W
0,1W
3157 ©
3158 ©
3159 ©
3160 ©
3161 ©
4822 117 10837
4822 051 20471
4822 051 20471
4822 051 20471
4822 051 20223
100kΩ
470Ω
470Ω
470Ω
22kΩ
1%
5%
5%
5%
5%
0,1W
0,1W
0,1W
0,1W
0,1W
3167 ©
3168 ©
3169 ©
3170 ©
3171 ©
4822 051 20121
4822 051 20121
4822 051 20154
4822 117 10837
4822 117 10834
120Ω
120Ω
150kΩ
100kΩ
47kΩ
5%
5%
5%
1%
1%
0,1W
0,1W
0,1W
0,1W
0,1W
3172 ©
3176 ©
3180 ©
3190 ©
3191 ©
4822 051 20562
4822 051 20333
4822 117 10833
4822 051 20121
4822 051 20121
5,6kΩ
33kΩ
10kΩ
120Ω
120Ω
5%
5%
1%
5%
5%
0,1W
0,1W
0,1W
0,1W
0,1W
3192 ©
3193 ©
3194 ©
3195 ©
4101 ©
4822 117 13577
4822 117 13577
4822 117 11449
4822 051 20101
4822 051 20008
330Ω
1%
0,1W
330Ω
1%
0,1W
2,2kΩ
1%
0,1W
100Ω
5%
0,1W
CHIP JUMPER 0805
4102 ©
4104 ©
4105 ©
4106 ©
4107 ©
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
2108 ©
2109 ©
2120 ©
2120 ©
2122 ©
5322 122 32531
5322 122 32448
4822 126 13689
5322 122 32658
4822 122 33891
100pF
10pF
18pF
22pF
3,3nF
5%
5%
1%
5%
10%
50V
50V
63V
50V
63V
2123 ©
2124 ©
2125 ©
2127 ©
2128
2020 552 93494
4822 122 33177
2020 552 96199
4822 126 14076
4822 124 40248
390pF
10nF
560pF
220nF
10µF
1%
20%
1%
20%
20%
50V
50V
50V
25V
63V
2129
2130 ©
2131 ©
2132 ©
2133
4822 124 41584
5322 122 32654
4822 126 13482
4822 126 13482
4822 124 21913
100µF
22nF
470nF
470nF
1µF
20%
10%
20%
20%
20%
10V
63V
16V
16V
63V
2134 ©
2134 ©
2135 ©
2135 ©
2136 ©
3198 017 31530
5322 122 32654
3198 017 31530
3198 017 32230
4822 126 14076
15nF
22nF
15nF
22nF
220nF
10%
10%
10%
10%
20%
50V
63V
50V
25V
25V
2137 ©
2138
2139 ©
2140 ©
2141 ©
4822 126 14076
4822 124 22652
4822 126 14236
4822 126 13695
4822 126 13838
220nF
2,2µF
15pF
82pF
100nF
20%
20%
5%
1%
10%
25V
50V
50V
63V
50V
2143 ©
2144
2145 ©
2146 ©
2147 ©
4822 126 14076
4822 124 21913
4822 122 33575
4822 122 33575
4822 122 33575
220nF
1µF
220pF
220pF
220pF
20%
20%
5%
5%
5%
25V
63V
50V
50V
50V
2148 ©
2149 ©
2150 ©
2159 ©
4822 122 33127
5322 122 32659
4822 126 13838
5322 122 31151
2,2nF
33pF
100nF
22µF
10%
5%
10%
20%
63V
50V
50V
50V
2163 ©
2164 ©
2165 ©
2166 ©
2167 ©
4822 126 13838
4822 126 13482
4822 126 13838
5322 122 31647
4822 122 33926
100nF
470nF
100nF
1nF
12pF
10%
20%
10%
10%
5%
50V
16V
50V
63V
50V
LW only
2169 ©
2180 ©
2190 ©
2191
4822 122 33127
3198 017 31030
4822 126 13838
4822 124 40178
2,2nF
10nF
100nF
100µF
10%
10%
10%
20%
63V
50V
50V
10V
RDS only
LW only
LW only
FM/AM only
1kΩ
5% 0,06W
22kΩ
5%
0,1W
56kΩ
1%
0,1W
TRIMPOT. 100kΩ
22kΩ
5%
0,1W
LW only
RDS only
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6105 © 4822 130 83075 HN1V02H
6106 © 4822 130 83757 BAS216
6107 © 9340 386 90115 BZX284-C11
6120 © 4822 130 83757 BAS216
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
RDS only
7103 © 5322 130 42756 BC857C
7104
9322 003 64676 TBC337-40
LW only
7105
9322 003 64676 TBC337-40
LW only
7109 © 4822 130 60373 BC856B
LW only
7110 © 4822 130 60373 BC856B
RDS only
7111 ©
7112
7122 ©
7124 ©
5322 130 42755
4822 130 44503
5322 130 42755
5322 130 42755
BC847C
BC547C
BC847C
BC847C
LW only
LW only
LW only
LW only
LW only
FM/AM only
not USA
USA only
not USA
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7101
4822 209 90315 TEA5762H/V1, RADIO IC
USA only
RDS only
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3105 © 4822 117 11503
220Ω
5%
0,1W
3108 © 4822 117 11449
2,2kΩ
1%
0,1W
LW only
3109 © 4822 051 20472
4,7kΩ
5%
0,1W
LW only
3123 © 4822 051 20472
4,7kΩ
5%
0,1W
LW only
3125 © 4822 117 10833
10kΩ
1%
0,1W
LW only
RDS only
LW only
FM/AM only
FM/AM only
FM/AM only
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
5102
4822 157 71634 RF-COIL MW
5103
2422 549 44107 RF-COIL LW
LW only
5109
4822 157 71639 FM-IF FILTER 10,7MHz
5110
4822 242 70665 FM-IF FILTER 10,7MHz
5111
2422 549 44023 AM-IF FILTER 450kHz
5112
5114
5115
5118 ©
5119
4822 157 70302
4822 157 70302
4822 157 71636
2422 535 95881
4822 157 11443
AM-IF FILTER 450kHz
AM-IF FILTER 450kHz
ANTI BIRDY FILTER
100nH
DISCRIMINATOR COIL
5121
5122
5123
4822 242 10261
2422 549 44108
2422 549 44108
QUARTZ 75kHz
RF-COIL, LW-OSCILLATOR
RF-COIL, MW-OSCILLATOR
LW only
10-1
5DTC Module
(MP3 version)
TABLE OF CONTENTS
Service hints ...............................................................................10-2
Location of Printed Circuit Boards ..............................................10-5
Wiring..........................................................................................10-6
Emergency opening ....................................................................10-7
Location of switches....................................................................10-8
Blockdiagram ..............................................................................10-9
CD BOARD
Circuit Diagram .....................................................................10-10
Component Layout side A .....................................................10-11
Component Layout side B .....................................................10-12
CONTROL BOARD
Circuit Diagram .....................................................................10-13
Component Layout ...............................................................10-13
MP3 BOARD
Circuit Diagram .....................................................................10-14
Component Layout ...............................................................10-15
Exploded view loader ...............................................................10-16
Partslist .....................................................................................10-17
Layout stage .4
Service Hints
In case of symptom „skipping tracks“ perform
following actions:
10-2
3. MEASURE THE EYE-PATTERN SIGNAL
EYE-PATTERN SIGNAL – JITTER MEASUREMENT
1. VERIFY THE COMPLAINT
11 D4
EYE-PATTERN
10 D3
Use CDDA SBC 444A: . . . . . . . . . . . . . .4822 397 30245
TR 14 (600µ black dot) maximum at 01:15
TR 19 (fingerprint)
TR 10 (1000µ wedge)
D2
9 D2
800mVpp
D1
8 D1
2K7
2K2
3908
820R
3907
0,65V
7877
BC847B
2887
4u7
2817
3899
2,6V
2881
2 HFIN
1 HFREF
LDON
64
LDON
to 3826,3827
470R
3906
560p
HFIN
3897
220R
7878
BC847B
3909
82p
2882
1,2V
4n7
3 ISLICE
100p
3K3
5 VDDA1
22n
3K3
6 IREF
33K
470n
560R
3898
470n
3904
2884
3903
2813
2816 2815
1K5
3902
220u
2885
3901 1,8V
2,4V
2883
VREF GE
4 VSSA1
2814
3905
680R
3920
100R
100R
Σ (A-D)
Before touching the lens it is advised to clean
the surface of the lens by blowing clean air over
it in order to avoid that little particles make
scratches on the lens.
27K
3896
+3.3V
7876
BC847B
7 VRIN
3895
47n
HF-Amplifier
+5V_HF
• playback of all these tracks without audible disturbance
• jump forward/backward within a reasonable time
CD DRIVE – LENS CLEANING
2818
470R
47n
3893
VrefCD10
TB = 0.5µs/div
Use CD-RW Printed Audio Disk . . . . . . .7104 099 96611
TR 3 (Fingerprint)
TR 8 (600µ black dot) maximum at 01:00
2. CLEAN THE LENS
D3
3n3
PLAYABILITY CHECK
Measure the signal direct on resistor 3898 using an
oscilloscope (see also chapter 10-9).
CD_DA: 0V / CD_RW: 3V
3923
+3.3V
10K
Sanyo
DA12T3
Drive detection
See below examples of the signal. Amplitude should read at
least 700mVpp using SBC444A.
Because the material of the lens is synthetic and coated
with a special anti-reflectivity layer, cleaning must be
done with a non-aggressive cleaning fluid. It is advised to
use “KODAK LENS CLEANER CAT 176 71 36”, available
in normal photo shops.
The actuator is a very precise mechanical component
and may not be damaged in order to guarantee its full
function. It is advised to clean the lens gently (don’t press
too hard) with a soft and clean cotton bud moistened with
the special lens cleaner.
The direction of cleaning must be in the way as indicated
in the picture below.
good
bad
If the oscilloscope shows a signal like the ‘bad’ one, and/or
the amplitude decreases within 1minute - the CD drive has
to be replaced.
10-3
Service Hints
4. MEASURE THE LASER CURRENT
6. MEASURE THE OFFSETS OF THE CD10
CD DRIVE – LASER CURRENT MEASUREMENT
SIGNAL PROCESSOR – OFFSET MEASUREMENT
The laser current can be measured as a voltage drop on
resistor 3820. Typical value 170 - 190mV for CD-DA
respectively 200 - 220mV for CD-RW.
Each ADC input of the CD10 may have an offset too.
Also this offset leads (together with the offsets of the CD
Drive) to poor playability of some CDs (skipping tracks).
Laser power control
Start the Service Test Program - section „Focus Test“
using a CD-RW disc.
U >250mV
->Laser damaged !
Use a DC Millivoltmeter for measurement. The offsets
can be measured on capacitors near the signal
processor. See drawing below.
3820
+5V
470n
100n
2841
10K
0,17V
2
CD Board side A view
33p
2880
3
1n
0,17V
2879
100n
3822
47u
2878
47n
2869
The value should read 0mV±10mV.
4,6V
7811-A
8
LM358D
3823 1
3V
1K
4
3,3V
7879
BC807-40
2V
LASER DIODE
1R
3,9V
4R7
2877
3821
47R
47R
3819
47R
3818
3817
2876
+5V_HF
5. MEASURE THE OFFSETS OF THE CD-DRIVE
CD DRIVE – OFFSET MEASUREMENT
Signal Processor
Each photodiode of the CD-drive may have an offset.
This offset has to be compensated by the signal
processor. A high offset of the CD-drive leads to poor
playability of some CDs (skipping tracks).
Start the Service Test Program - section „Focus Test“
without a CD. Focus sensitivity = CD-RW.
Use a DC Millivoltmeter for measurement. The offsets
can be measured direct on the connector. See drawing
below.
The values from diode A-D should read 0±10mV.
Diodes E and F are less critical.
B
A
C
D
F
E
VREF
3
4
5
If one of the offsets is higher than ±10mV the signal
processor has to be replaced.
CD Drive
Sanyo DA12T3
1800
E
VREF
16
VCC
15
E
14
D
13
A
12
B
11
C
10
F
9
GND
8
B
A
C
D
F
VrefCD10
+5V_HF
E
E
D
D
A
A
B
B
C
C
F
F
If one of the offsets is higher than ±10mV the CD drive
has to be replaced.
If none of the measured offsets is higher than ±10mV replace the part with the higher value.
10-4
WARNING
CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE CD DRIVE ELECTRONICS WHEN
CONNECTING A NEW CDM MECHANISM. THAT´S WHY, BESIDES THE SAFETY MEASURES LIKE
• SWITCH OFF POWER SUPPLY
• ESD PROTECTION
ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN.
The CD drive forms a compact building block with the CD Board.
The following steps have to be done when replacing the CD mechanism:
1. Desolder disc and slide motor
2. Loosen 2x screw
1. Disconnect flexfoil from old CD drive
2. Put a paperclip over contacts of flexfoil to short-circuit the contacts (fig.1)
3. Remove old CD drive
4. Mount new CD drive to CD board
5. Solder disc and slide motor after fixing the drive to the board
5. Move slide outside
6. Remove paperclip from flexfoil
7. Connect flexfoil to new CD drive
8. Remove ESD-protection (solder joint) from laserunit (see picture below)
fig.1
Attention: The laser diode of this CD drive is protected against ESD by a solder joint which shortcircuits the
laserdiode to ground.
For proper functionality of the CD drive this solder joint must be removed after connection the drive to
the set.
10-5
Location of Printed Circuit Boards
CD Board
MP3 Board
Motor
Board
1
5
80
80
52
80
21
Control
Board
5DTC Location of PCBs 2002 08 29
10-6
Wiring Diagram 5DTC Module
MP3 Board
1801
1451
Control Board
8021
1802
Motor Board
8051
8052
1820
to /
fr
CD- om
driv
e
1823
1824
1825
8001
to / from
AF Board
dig.out
(optional)
1800
CD Board
5DTC Wiring Diagram 2002 08 30
The FFC-Cables are available as sparepart.
8001
8051
8052
8021
3103 308 93090
3103 308 93100
3103 308 93120
3103 308 93110
FFC CABLE 16Pin 80mm BD
FFC-CABLE 19Pin 90mm AD
FFC CABLE 8Pin 80mm BD
FFC-CABLE 16Pin 60mm AD
Connection from CD Board to CD Drive
Connection from CD Board to MP3 Board
Connection from CD Board to Control Board
Connection from Control Board to Motor Board
10-7
Emergency opening of the trays
The trays of the 5DTC are mechanically
locked.
To open tray 1, 2 and 3 move lever (pos 29) backwards
(e.g. with a screwdriver - see picture 2) to its endposition.
Release snap as shown in picture 5 and pull tray out.
To remove a CD from Play Position perform following
steps:
1. Open tray 1 as described before.
2. Tear the tray out with speed (see picture 6). The tray can
be inserted aftewards without any alignment.
Release the locking mechanism and pull out the tray (see
picture 3).
3. Move lever (pos 29) forward to its endposition (see
picture 4).
4. Push lever (pos 31) forward (see picture 7).
To open tray 4 and 5 move lever (pos 29) forward to its
endposition (see picture 4).
5. Remove CD.
10-8
Location of switches
10-9
10-9
BLOCK DIAGRAM 5DTC MP3 Version
CD MECHANISM
CD MAINBOARD
+5V
DISC
22
5,17,21,52,57
Vref
23
TURNTABLE
MOTOR
FOCUS
MOTOR
VCC
Vref
25
27
FOCB-
55
LP
LN
FO
1824
7887
8
5
19
+
18
6
1
CD LEFT
7
-
Active low pass
Filter
18
RADB+
RADIAL
MOTOR
+5V
7800
MM1469PH
26
FOCB+
+3,3V
7802
Vref
RP
19
17
RADB-
54
RA
RN
3
23
+
22
2
SCLI
37
IIS_SCLK
SDI
36
AU_IIS_DATA
WCLI
35
IIS_WCLK
DATA
27 CD_IIS_DATA
2
Analog Audio
LM358
1
3
CD RIGHT
-
4
1820
2
Vref
SLEDGEB+
SLEDGE
MOTOR
3
1
56
SIGNAL PROCESSOR
CD10
SL
SAA7324 (SAA7325)
SLEDGEB-
CD-DA coded
DIGITAL AUDIO
AU_IIS_DATA
16
IIS_SCLK
13
IIS_WCLK
15
CD_IIS_DATA
17
MP3 BOARD
AU_IIS_DATA
MP3-Decoder
IIS_SCLK
IIS_WCLK
MP3 coded
11
TTM-
TURNTABLE
MOTOR
WCLK 28
Vref
7811
59
60
10
12
TTM+
MOT1
MOT2
SCLK
29
IIS_WCLK
IIS_SCLK
8,13,15,16,28,29,30
LASER &
MONITOR
DIODE
7811,7879
64
LD ON
LD
SILD
42
8
RAB
41
9
SCL
40
10
39
11
RESET
EQ-Selection
A-C
2
F
HF IN
D1
D2
D3
D4
R1,R2
DOBM
51
6
Digital out
V1
1,5,12,14,18
GND
63
MOTOR BOARD
CONTROL BOARD
+5VSWITCH
3
A
19
µP_CLK
2
µP_DATA
3
+5V
µP_CLK
µP_DATA
µP_FRAME 4
+5VSWITCH
µP_FRAME
7801
2
HOLDER HEIGHT COLLECTOR
GND
1
HOME SW
4
HOME SW
5
6
OPEN SW
GND
7
OPEN SW
8
GND
UNLOAD SW
9
UNLOAD SW
10
11
LOAD SW
GND
LOAD SW
DISC SENSOR COLLECTOR
8
11
HOME SW
9
µP_FRAME
7
12
µP_CLK
OPEN SW
6
UNLOAD SW
5
LOAD SW
ADDRESS2 SW
TRAY_IRQ
12
ADDRESS2 SW
4
CLOSE SW
I2C_SCL
13
ADDRESS3 SW
1802
4
19
14
µP_DATA
1823
16
9
Tray_IRQ
8
Tray_IRQ
Tray_IRQ
5
Tray_I2C_SCL
8
Tray_I2C_SCL
Tray_I2C_SDA
7
Tray_I2C_SDA
7
Tray_I2C_SCL
Control Logic
12
CLOSE SW
+AOPAMP
I2C_SDA
Micro Controller
5
3
ADDRESS2 SW
24
ADDRESS3 SW
RST
VDD
VREF
6
27
µC_RESET
7
5
8
4
10
µC_RESET
µC_RESET
28
13,15
8
9,10
+A
+AOPAMP
23
11
2,3
1824
+A (+12V)
1
1824
+AOPAMP
2
LIFT
MOTOR
GND
+5VST
7
1
TRAY
MOTOR
6
Tray_I2C_SDA
TMP87CA409A
6
13
ADDRESS3 SW
16
17
7803
TCA0372
ADDRESS1 SW
GND
Pin 1..3 not used!
11
ADDRESS1 SW
2
ADDRESS1 SW
10
HOLDER HEIGHT COLLECTOR
CLOSE SW
E
SPDIF
For DIGITAL OUT versions only
+5V
D
SDA
7876,7877
INNER SWITCH
C
SICL
7878
not on all versions
B
Communication
DSP ↔ Signal Processor
V4
A-D
+5V
SILD
RAB
Communication
Front-µP and MP3 module
A B
7
SDA
PHOTO
DIODES
D C
61
CD RW= 3V
CD DA= 0V
MON
E
38
RESET
CD_IIS_DATA
+5VST
7805
+12V
+8V
6
+A
TCA0372
1
15
8
26
7800
VREF
7801
7
3
6
5
4
+5V
VREF
14
5
+5VSWITCH
21
+3,3V
1
1800
Supply
+5V
7806
+5V
OSC.
1801
GND
2
+3servo
7815
Vref
CST
8M
Blockdiagram 5DTC 2002-09-05 MP3 Version
10-10
11
12
13
3912
1
3829
22K
3879
680R
4K7
4K7
3883
3884
100p
2848
220u
18K
22K
3840
680R
3870
18K
100p
2843
120p
RAB
9
SICL
10
SDA
11
13
10K
3888
10K
IIS_SCLK
14
Inner switch
detection
4K7
TEST2
EF
SCLK
WCLK
CL16
TEST1
SELPLL
RP
RN
LP
TIMING
+3.3V
IIS_WCLK
15
AU_IIS_DATA
16
CD_IIS_DATA
17
IIS_WCLK
Digital Audio Data 3916
SDI 36
3832
AU IIS DATA
19
+5V
20
IIS_SCLK
21
2827
1n
3837
PORE
3910
SDA
2828
27p 3839
SICL
3849
RAB
3845
SILD
57
56
55
54
53
DOEM
VDDD1P
CFLG
RA
FO
SL
VDDD2C
MOTO1
MOTO2
V5
V1
VSSD3
58
INTERF.
EBU
STAGES
OUTPUT
SILD 42
0V
3V
+5V
52
51
50
Tray_IRQ
8
Tray_I2C_SCL
7
Tray_I2C_SDA
6
uC_RESET
5
4
3
SPDIF
2
+5V
100R
For sets with DIGITAL OUT only
M1
+3.3V
SL
FO
1
4
+5V
7875
BC847B 4,9V
3,3V
8
GND
IIS_SCLK
GND
IIS_WCLK
AU_IIS_DATA
CD_IIS_DATA
D
GND
+5V
GND
GND
1,65V
9
10
10n
uC_RESET
+A
+A
GND
H
LEFT
GND A
RIGHT
+5V
GND
+A
Tray_I2C_SDA
Tray_I2C_SCL
8
Tray_I2C_SCL
Tray_IRQ
9
uC_RESET
10
33R
uP_FRAME
11
uP_CLK
12
150R
uP_DATA
14
15
12
13
14
15
I
Tray_IRQ
uC_RESET
uP_FRAME
uP_CLK
GND
uP_DATA
GND
5DTC CD Board MP3 Version 2002 09 18
11
G
GND
7
13
2853
1,45V
Tray_I2C_SDA
Tray_I2C_SDA
3880
3881
3844
Tray_IRQ
Tray_I2C_SCL
6
+3.3V
100R
2,9V
2812
7
+A
12V
IN
5V
6877
+3servo
VrefCD10
6
5
2824
OUT
2
3
RA
1u
8V
PDZ-3.9B
B3V9
brakes
disc
SDA
1824
LEFT
0V
Analog Audio
1K
12K
C
SICL
to / from
Audio / Combi Board
3V
4R7
10K
3922
Mitsumi
MCD2
1K
+3.3V
RAB
1823
0V
3860
SILD
E
SBSY 48
CL11|4
49
+3servo
5002
47u
3891
0V
0V
CD10_RESET
F
SFSY 47
470R
2831
During brake
accelerates
disc
3859
100K
3V
CH-B
SPDIF
to / from
5DTC Control Board
SUB 46
100n
10K
Sanyo
DA12T3
Drive detection
47u
100K
CH-A
SPDIF_GND
470R(8x)
RCK 45
3838
3923
1K
39K
3836
DSP_FRAME
RAB 41
2886
1u
+8V
B
DSP_DATA
SCL 40
TEST3 44
DET.
PEAK
3917
3909
59
2847
M2
Vref
5
8
L7805
7801
33n
4
7
SILD
RIGHT
15
3
60
+3.3V
8,13,29,30
2
PORE
1
10u
+
-
61
100K
62
16
14
6
18
SDA 39
SUBCODE
PROCESSOR
47n
2887
3897
33K
100p
22n
3n3
2816 2815
V4
47n
2818
4u7
2817
3905
680R
2814
3907
63
2830
Vref
SPDIF
DSP_CLK
STATUS 43
CORR.
ERROR
CONTROL
MOTOR
INTERFACE
VERSATILE
3892
6
7878
BC847B
3842
23
+
-
INTERF.
VERSAT. V2|V3 34
SRAM
CD_DA: 0V / CD_RW: 3V
39K
2840
VREF
+
2K7
1K
5
V
6
3855
Motor Driver
...V DC voltages measured in
PLAY MODE
with following conditions:
EVM
"+A" = 12V
"+5V" = 5V
5
1,2V
VSSD1 33
ADDR
PLL
DIG.
M2
During speed up
1,2V
1K
1 HFREF
LDON
64
3843
VREF
Driver
Mute
7
10
END
FRONT
2 HFIN
47n
12
7811-B
LM358D
7
1,7V
9
HFIN
2829
M DISC
+
KILL
RESET 38
3 ISLICE
3899
Vref
3862
Level shift
11
DEMOD
EFM
5 VDDA1
LDON
to 3826,3827
0,65V
M1
4K7
VREF
I
220R
470R
7877
BC847B
6 IREF
SL
2852
SLIDE
4n7
4
+5V
3
4
+3.3V
32
INTERF.
LOOPBACK
SER. DATA
VREF GEN.
7 VRIN
27K
470n
2885
2882
820R
2839
2
+
470n
M SLIDE
J
220K
220R
3856
2838
Level shift
1
3846
47K
3826
3851 RA
VREF
+5V
8K2
3852
15K
5001
TRACK
1,2V
560p
3841
15K
3K3
3898
2,6V
15K
20
3919
820R
33n
18
19
220R
100n
T+
+
2853
17
470n
3K3
2881
3861
Vref
3847 FO
15n
FOCUS
Level shift
T-
3904
2813
uP FRAME
WCLI 35
PROCESSOR
AUDIO
FUNCTION
CONTROL
4 VSSA1
3906
3848
15n
10K
VREF
H
100n
2841
1R
3821
25
2832
1s
24
3918
2834
27
+
3903
560R
47K
F-
Σ (A-D)
47K
26
3901 1,8V
Vref
3850
+ 2V
-
F+
21
Vcc
3854
Focus search
22
Vcc
10n
F-
2833
7802
MM1469PH
10n
1
7876
BC847B
2,4V
2883
2884
T-
+8V
2K2
2
100R
T+
1K5
3
2K7
3908
F+
820R
4
3920
4R7
ESD sensitive lines!
3872
From 7800
pin64
3902
MON
5
100R
LDON
0,17V
3
GND
3895
3896
+3.3V
220u
6
2
470R
HF-Amplifier
82p
GND
KILL
D1
+5V_HF
2K7
2V
31
30
SAA7325
7800
PRE-
3893
0,17V
3
IIS_WCLK
3911
470n
2876
47R
47R
3819
3818
47R
3866
29
INTERFACE
SER. DATA
ADC
VrefCD10
TB = 0.5µs/div
47n
7
2837
LD
47u
8
4,6V
7811-A
8
LM358D
3823 1
3V
1K
4
3,3V
7879
BC807-40
2836
GND
3,9V
10K
F
B
100n
3822
9
47u
2878
C
F
2877
11
10
TRACK
G
FOCUS
F
B
C
28
27
8 D1
47n
F
2869
D
uP DATA
5
CD_IIS_DATA
PROCESSING
D3
800mVpp
3824
A
26
9 D2
470K
3825
D
12
10u
2
SCLI 37
D2
3827
13
A
Level shift
A
25
24
Signal Processor
11 D4
EYE-PATTERN
+3.3V
3828
D
B
C
4R7
33p
E
+5V_HF
23
BITSTREAM DAC
10 D3
2880
14
22
12 R1
+5V
+5V_HF
180R
RIGHT
uP CLK
12
R1
2K2
1n
E
19
D4
2879
15
3817
E
VCC
2846
470R
13 R2
3815
3820
VrefCD10
3871
IIS_SCLK
MICROCONTROLLER
INTERFACE
16
VREF
1n5
14 VSSA2
2K2
1800
E
220u
20
21
R2
3816
A
1820
Digital MP3 Data
VSSD2
Sanyo DA12T3
3868
3875
D
2K2
B
A
to / from
MP3 Board
3831
3814
U >250mV
->Laser damaged !
1n5
15 CROUT
2K2
CD Drive
16 CRIN
3813
2825
18
VDDA2
CST
8M467
Laser power control
47n
470R
2823
LN
1810
C
3
2,4V
3889
2822
VNEG
33p
2819
33p
2820
2875
220p
PHOTODIODES A..F
D
10u
LEFT
3878
17
D
180R
3890
D1 (CD10)
10K
2865
180p
47K
2851
470R
VPOS
3812
3806
7810-A
LM358DT
1
3V
2,4V
2
100n
120R
For sets with
DIGITAL OUT only
2821
+3.3V
C
B
3,2V
33K
120R
3833
3867
100R
+3.3V
D2 (CD10)
33K
2844
220p
2873
47K
10K
2874
3811
2864
3805
100R
RIGHT CHANNEL
3928
D3 (CD10)
220p
2863
10K
180p
47K
180p
A
3810
4
3865
Active Low Pass
3864
DATA
2871
220p
B
3804
5
2,4V
2826
7810-B
LM358DT
7
3V
8
2,4V
6
1
3927
C
18K
33K
120p
100R
D4 (CD10)
2872
10K
3874
15
220p
2861
47K
2866
3809
33K
R1 (CD10)
10K
3803
180p
D
150p
56K
3808
100R
LEFT CHANNEL
3926
220R
2855
3802
F
3873
2849
A
3925
220u
2870
10K
R2 (CD10)
220p
56K
2860
3807
150p
E
3801
2854
+8V
5DTC CD BOARD
14
6,1V
18K
10
3877
9
3876
8
120p
7
3869
6
3835
5
3834
4
2850
3
120p
2
2845
1
10-10
J
10-13
1
10-13
2
3
4
Mapping
5DTC CONTROL BOARD
1802
5
4
I2C_SDA
I2C_SCL
2
47u
2808
+5VST
5V
+A to +5V
stabilization
TRAY_IRQ
3861
2K0
+5VST
TO / FROM
CD MAIN BOARD
3860
100R
VREF
4,1V
100n
TRAY_IRQ
6
3845
10K
I2C_SCL
7800
MC78L05
1
3
7
uC_RESET
+AOPAMP
11,8V
2810
I2C_SDA
8
2R2
3862
uC_RESET
1R5
100n
GND
Stabilized +5V
switched by µC (7801)
7806
BC857BW
+5VSWITCHED
5V
+5VST
3859
B
DISC SENSOR
COLLECTOR
HOME SW
HOLDER HIGHT
COLLECTOR
ADDRESS1 SW
D
ADDRESS2 SW
ADDRESS3 SW
TR +
3815
3850
820R
10K
3801 4K7
6
4K7 3809
7
3804 4K7
4K7 3807
3805 4K7
4K7 3802
3806 4K7
4K7 3803
8
9
10
24
TR -
23
LI -
21
LI +
4,1V
6
3819
3851
820R
10K
C1
C3
C4
D4
D3
D3
E4
C4
3824
3826
3827
3828
3829
3830
3831
3832
C3
A2
C1
C2
B1
B1
B1
E4
3833
3834
3835
3836
3837
3838
3839
3840
E4
E3
E3
E3
E3
E3
E3
E3
3841
3842
3843
3845
3850
3851
3852
3853
E3
C2
C2
A2
C3
D3
D3
C3
3854
3855
3856
3857
3858
3859
3860
3861
B3
D3
D3
C3
B2
B3
A2
A2
3862
3863
4808
7800
7801
7803-A
7803-B
7805-A
A3
A2
B2
A2
B2
D3
C3
C3
7805-B D3
7806
B3
B
1800
1801
1802
2800
2801
2802
2803
2804
2805
2808
2809
B2
C4
C2
D2
D2
A2
B1
C2
C1
A6
C2
2810
2811
2812
2813
2814
3800
3801
3802
3803
3804
3805
A5
A5
A6
B5
B6
B2
C3
C4
C4
C3
C4
3806
3807
3808
3809
3810
3811
3812
3813
3815
3816
3818
C4
C3
B2
C3
C2
A2
A1
B2
A4
A5
A6
3819
3820
3821
3823
3824
3826
3827
3828
3829
3830
3831
A4
A4
B5
B6
A4
B6
B2
C2
B2
C2
C1
3832
3833
3834
3835
3836
3837
3838
3839
3840
3841
3842
C4
B2
C4
C2
C4
C3
C4
C3
C4
C3
A2
3843
3845
3847
3848
3850
3851
3852
3853
3854
3855
3856
A2
D2
B1
B1
A4
A4
A4
A4
B5
B5
A6
3857
3858
3859
3860
3861
3862
3863
4800
4801
4802
4803
A5
B5
C5
C5
B5
A5
B6
C2
C2
C2
D1
4804
4805
4806
4807
4808
4809
4810
4811
4812
4813
4814
A2
C1
A2
C1
C2
C5
B2
C1
B2
B6
A4
4816
4817
4818
4819
4820
4821
4822
6801
7800
7801
7802
D2
A6
C5
A6
B5
C3
C3
B1
D2
B4
A2
7803
7804
7806
9801
9802
9804
47R
5DTC Control Board Copperside view
TRAY-
TCA0372
7803-A
4,1V
8
3,3V
1
4,1V
7
22
2
+AOPAMP
12
LIFT-
D
3855
15
13
3811
3815
3816
3818
3819
3820
3821
3823
10K
LI -
VREF
NC
4K7
D1
D1
D1
D2
D1
D2
D2
B1
3856
25
11
10K
TCA0372
7803-B
3,3V
3
4
4,1V
5
3804
3805
3806
3807
3808
3808
3809
3810
C
3857
100n
5
2
+AOPAMP
For sets
with
disc sensor
A3
D4
D4
E4
C4
C1
D2
D2
2814 3823
VREF
(either/or)
2810
2811
2812
2813
2814
3800
3802
3803
TRAY+
47R
100n
4
3,3V
1
4,1V
7
C2
E4
A1
A2
A2
B2
C1
A2
MAPPING FOR COMPONENT LAYOUT
TCA0372
7805-A
100n
10K
VREF
4K7 3808
A
1800
1801
1802
2800
2801
2802
2803
2808
3816
3842
26
RST
Input / Output PORT
OPEN SW
820R
4,1V
8
TEST
Input / Output PORT
UNLOAD SW
18
TR -
3800
MAPPING FOR CIRCUIT DIAGRAM
2811
3811
150K
2803
LOAD SW
2
3853
For sets
without
disc sensor
Power on
Reset
27
CLOSE SW
STOP
XTAL
8MHz
3
uC_RESET
1
3824
47R
2
3843
1
TR +
INT 0
Micro
Controller
1800
+5VST
+5VST
2812 3818
SCL
100R
E4
E4
E3
E3
E3
E3
E3
E3
E3
E3
C2
C2
A2
C3
D3
D3
C3
B3
D3
D3
C3
B2
B3
A2
A2
A3
A2
B2
A2
B2
D3
C3
C3
D3
B3
10K
1K
100n
16
3832
3833
3834
3835
3836
3837
3838
3839
3840
3841
3842
3843
3845
3850
3851
3852
3853
3854
3855
3856
3857
3858
3859
3860
3861
3862
3863
4808
7800
7801
7803-A
7803-B
7805-A
7805-B
7806
3854
3858
GND
LI +
14
3820
3852
820R
10K
10K
TCA0372
7805-B
3,3V
3
4
4,1V
5
4,1V
6
VREF
LIFT+
47R
3827 100R 19
20
3821
TRAY_IRQ
INT 1
2813
100R 3828
C2
E4
A1
A2
A2
B2
C1
A2
A3
D4
D4
E4
C4
C1
D2
D2
D1
D1
D1
D2
D1
D2
D2
B1
C1
C3
C4
D4
D3
D3
E4
C4
C3
A2
C1
C2
B1
B1
B1
28
VCC
SDA
10K
I2C_SCL
17
10K
3829
100n
2802
3810
3830
3831
10K(3x)
7801
TMP87C409A
I2C_SDA
C
10K
4808
+5VST
4,3V
100n
A
12V
9
3863
2801
+A
3826
+A
10
220n
+A
!
11
2800
GND
1800
1801
1802
2800
2801
2802
2803
2808
2810
2811
2812
2813
2814
3800
3802
3803
3804
3805
3806
3807
3808
3808
3809
3810
3811
3815
3816
3818
3819
3820
3821
3823
3824
3826
3827
3828
3829
3830
3831
+5VST
TO / FROM
MOTOR BOARD
F
V
...V DC voltages measured in
PLAY MODE
with following conditions:
EVM
"+A" = 12V
2K7
2K7
3832
2K7
3833
2K7
3834
2K7
3835
10K
3836
2K7
3837
2K7
3838
2K7
3839
3841
SWITCH / STATUS RECOGNITION
10K
3840
E
LIFT-
16
TRAY+
15
LIFT+
14
TRAY-
13
ADDRESS3 SW
12
CLOSE SW
11
ADDRESS2 SW
10
LOAD SW
9
ADDRESS1SW
8
UNLOAD SW
7
HOLDER HEIGHT
COLLECTOR
OPEN SW
6
HOME SW
4
5
LIFT+
TRAYADDRESS3 SW
CLOSE SW
ADDRESS2 SW
LOAD SW
ADDRESS1 SW
UNLOAD SW
HOLDER HEIGHT
COLLECTOR
3
4
HOME SW
5V
1
DISC SENSOR
COLLECTOR
2
TRAY+
3
2
1
LIFT-
OPEN SW
+5VSWITCHED
5 DTC Control Board CD/DVD Version 2002 09 12
E
1801
GND
DISC SENSOR
COLLECTOR
F
This assembly drawing shows a summary
of all possible versions.
For components used in a specific version
see schematic diagram respectively partslist.
5DTC Control Board Layout stage .3 2002-09-25
A5
B2
C5
C5
B2
A5
10-14
10-14
MP3 BOARD - CIRCUIT DIAGRAM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
MP3-CD-2002
DD6
106
A16
105
D5
104
DD5
11
D4
103
DD4
12
D3
102
DD3
13
9
10
AD16
8
A12
D2 101
DD2
AD13
9
A13
D1
100
DD1
AD14
10
A14
D0
99
DD0
AD15
11
A15
RS
98
2457
12
CVDD1
X2|CLKIN
97
10n
13
HAS
X1
96
20
PS
TMS
89
21
DS
TCK
88
100R
24
1
IOSTRB
EMU1|OFF
84
1M
26
MSC
EMU0
83
1460
BCLKX1
CVSS7
HD1
CVDD4
INT3
INT2
INT1
INT0
NMI
HBIL
IACK
BDX2
BDX0
HD0
75
DVSS3
DVDD4
DVDD3
76
HRDY
DVSS5
BFSX2
DVDD2
BFSX0
33
CVDD3
77
HINT
CLKMD1
CVSS6
MP|MC
BCLKX2
32
BCLKX0
78
BDR2
CLKMD2
37 38 39 40 41 42 43 44
20
AD4
21
AD3
22
AD2
23
AD1
24
NC
DQ3
RY|BY
DQ10
A18
DQ2
A17
DQ9
A7
DQ1
A6
DQ8
A5
DQ0
A4
OE
A3
VSS
A2
CS
A1
A0
DD4
36
DD3
34
DD10
33
DD2
32
DD9
31
DD1
30
DD8
29
28
3449
100n
100R
14
OE
8
7454-C
9
14
4452
WE
3
+3.3V
220R
3464
1451
10K
nRW
19
14 7454-D
12
13
CD_IIS_DATA
16
AU_IIS_DATA
15
IIS_WCLK
IIS_WCLK
14
7
7
IIS_SCLK
3479
470R
3496
3493
CD10_RAB
8
CD10_SILD
CD10_SILD
7
+5V
10K
3495
470R
SPDIF
5
SPDIF_GND
4
uP_FRAME
3
+3.3V
10K
4453
uP_CLK
BC847BW
7460
3488
100K
uP_DATA
3486
2
1K
1
3489
# .... only for FLASH version
.... only for ROM version
uP_DATA
uP_CLK
GND
FMN
+3.3V
10K
*
1
2
3
4
5
6
7
8
9
10
11
12
13
H
CD10_RESET
6
SPDIF
SPDIF_GND
uP_FRAME
3485
10K
3466
CD10_SICL
9
CD10_RAB
nCD10_RESET
CD10_SICL
CD10_SDA
10
CD10_SICL
150K
GND
11
CD10_SDA
TMS_RESET
G
GND
13
IIS_SCLK
nCD10_RESET
3494
100R
3490
AU_IIS_DATA
470R
3477
GND
17
CD_IIS_DATA
AU_IIS_DATA
for 5V front uP
CD10_RAB
1u
+5V
18
+3.3V
2467
100R
470R
3483
uP_DATA
CD10_SDA
3482
100n
15R
2469
3484
+3.3V
1u
2468
100R
uP_FRAME
uP_CLK
3452
100R
3481
IIS_SCLK
7452
F
7453
BC847BW
2
+3.3V
100R
100R
100R
3476
BZX284-C3V3
nMSTRB
+3.3V
IIS_WCLK
6450
BC847BW
5
11
E
3471 33R
12
*
+core
3K3
3469
100R
7456
BC847BW
7
14 7454-A
1
180R
3498
+5V
BZX284-C3V9
7
+3.3V
C
D
3458
1
4
10
+3.3V
+3.3V
74HC00D
BDX1 74
BFSX1 73
DVSS4
7455 LM317D
2 O1 ADJ 4
3 O2
5
6 O3
8
7 O4
IN
7454-B
6
4
Voltage stabilisation
+1.5V
27
25
SPDIF
SPDIF_GND
FMN
DD0
26
SPDIF_GND
3
DD11
35
1455
2
+3.3V
37
2471
1
45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72
H
I
10R
3453
38
6451
3472
3480 #
SPDIF
4450
10K
79
10K
80
3468
HPI16
CLKMD3
BIO
36
AD5
100n
81
3467
HD2
31
CVSS4
BDR1
19
DQ11
DD12
3459
16.93MHz
CSTCV
15R
82
3474
IAQ
HOLD
TOUT
2466
29
AD6
NC
3
25
30
18
VDD
39
AD0
2
3492
HOLDA
AD7
DQ4
Flash
EPROM
RESET
SPDIF_GND
nPS
TRST 87
XF
17
DQ12
WE
DD5
NC
85
35
100R
4
TDO
HCNTL1
3475
5 74HCT1G04
MSTRB
34
CD_IIS_DATA
7457
86
BDR0
100K
3473
15R
+core
TDI
28
3470
For Flash version: TMS320VC5416
For ROM version: TMS320VC5406
100n
16
AD17
NC
40
10K
R|W
2470
AD18
DQ5
DD6
DD13
3497
IS
23
+3.3V
DSP
+3.3V
47R
90
READY
1K
3491
91
CVSS8
HR|W
19
14
15
1u 2463
CVDD5
18
27
100n
92
HCS
22
F
2465
HPIENA
17
3462
100R
G
93
BFSR2
3463
94
DVSS6
BFSR0
nMSTRB
CLKOUT
CVDD2
16
BFSR1
CVSS5
BCLKR1
nRW
CVSS3
15
BCLKR2
nPS
95
DVSS1
BCLKR0
+core
HD3
14
DVSS2
1u
2462
provisional
7451
HCNTL0
1u
2459
2472
220u
+core
3455
NC
42
41
1K
AD12
DQ13
B
3460
A11
3456
7
DQ6
A8
DD14
100n
DVSS7
A9
DD7
43
2460
8
DQ14
3457
7
AD8
DQ7
A10
DD15
44
680R
AD9
AD17
A20
CVSS9
DVDD5
D6
D7
D8
D9
D10
D11
D12
HD4
D13
D14
D15
HD5
CVDD6
HDS1
DVSS8
HDS2
DVDD6
A0
A1
A2
A3
HD6
A4
A5
A6
A7
HD7
A8
6
A9
A10
AD18
107
AD11
D
E
5
108
A11
45
220u
C
DVDD1
6
46
2461
AD10
4
AD10
DQ15|A-1
100n
100n
CVSS2
5
VSS
A12
3487
15R
3
AD11
A13
47
100K
2455
4
A19
A18
A17
1K
3454
DVSS9
CVSS1
A22
CVSS10
+3.3V
1
2
CVDD7
Text version only
A21
144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109
AD12
48
2464
1u
3
BYTE
10K
4
AD13
A16
A14
100n
DD7
DD8
DD9
DD10
DD11
2454
100n
2
2456
1u
AD14
Am29LV800B
A15
3461 47R
2451
100n
2452
VSS
1
10n
2453
7450
AD15
2458
WC_
DD12
DD13
DD15
15R
3450
DD14
AD0
AD1
AD2
AD3
AD4
AD5
AD6
AD7
SCL
+3.3V
15R
+core
A
+3.3V
AD16
3451
5
3478
SDA
+1.5V
CD10_SILD
E2
M24C32
B
+core
470R
7
EEPROM
5450
6
+3.3V
+3.3V
600R
3
VCC
E0
E1
10K
2
100R
8
3499
1
7458
AD8
3465
100n
A
AD9
only for FLASH version
2450
14
I
2451 B5
2452 B2
2453 B4
2454 B7
2455 C2
2456 C12
2457 D9
2458 C10
2459 D2
2460 E13
2461 D12
2462 D2
2463 D8
2464 G12
2465 G2
2466 G8
2467 H6
2468 H4
2469 H5
2470 D9
2471 E11
2472 D1
3449 E11
3450 A4
3451 B7
3452 H3
3453 A12
3454 C1
3455 C9
3456 C10
3457 D13
3458 D14
3459 F13
3460 F13
3461 E12
3462 E2
3463 F1
3464 F13
3465 A2
3466 H8
3467 F8
3468 F8
3469 E13
3470 F1
3471 E13
3472 H9
3473 G2
3474 G8
3475 G2
3476 H2
3477 H7
3478 B6
3479 H8
3480 H2
3481 H3
3482 H5
3483 H6
3484 H5
3485 I11
3486 I13
3487 I12
3488 I12
3489 I12
3490 H8
3491 D9
3492 F9
3493 H12
3494 H8
3495 H11
3496 H8
3497 I13
3498 D14
3499 A2
4450 C13
4452 F9
4453 I11
5450 B3
6450 E13
6451 E13
7450 A10
7451 D5
7452 F13
7453 F12
7454-A G11
7454-B F11
7454-C F11
7454-D G11
7455 D13
7456 E12
7457 E9
7458 A1
7460 I12
10-16
Exploded view 5DTC mechanic - for orientation only
10-16
10-17
ELECTRICAL
PARTSLIST 5DTC MODULE MP3CD Version CD Board
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MECHANICAL PARTS
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3103 308 54710 5DTC Module (mechanic w/o electronic)
2869 © 3198 017 34730
47nF 10%
16V
201
3103 309 05390 CD DRIVE DA12T3
2870 © 4822 126 13883
220pF
5%
50V
252
4822 529 10387 Rubber damper CD DRIVE, FRONT
2871 © 4822 126 13883
220pF
5%
50V
253
4822 529 10386 Rubber damper CD DRIVE, REAR
2872 © 4822 126 13883
220pF
5%
50V
2873 © 4822 126 13883
220pF
5%
50V
MISCELLANEOUS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2874 © 4822 126 13883
220pF
5%
50V
3103 308 67020 MP3 Board
2875 © 4822 126 13883
220pF
5%
50V
1800
4822 267 11028 FFC-CONNECTOR 16P, Side entry
2876 © 3198 017 44740
470nF 20%
10V
1820
2877
4822 124 40433
47µF 20%
25V
1823
2878 © 2238 586 59812
100nF 10%
50V
1824
4822 265 10979 FFC-CONNECTOR, 15P, Side entry
2879 © 5322 126 11578
1nF 10%
63V
8001
3103 308 93090 FFC CABLE 16Pin 80mm BD
2880 © 2222 867 15339
33pF
5%
50V
8051
3103 308 93100 FFC-CABLE 19Pin 90mm AD
2881 © 4822 126 14249
560pF 10%
50V
8052
3103 308 93120 FFC CABLE 8Pin 80mm BD
2882 © 4822 126 14226
82pF
50V
2883 © 3198 017 44740
470nF 20%
10V
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2884 © 3198 017 44740
470nF 20%
10V
2812
4822 124 11947
10µF 20%
16V
2885
4822 124 40196
220µF 20%
16V
2813 © 4822 126 13193
4,7nF 10%
63V
2886 © 2238 586 59812
100nF 10%
50V
2814 © 5322 126 11579
3,3nF 10%
63V
2887 © 3198 017 34730
47nF 10%
16V
2815 © 2020 552 94427
100pF
5%
50V
2816 © 3198 017 42230
22nF 10%
50V
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2817
4822 124 22726
4,7µF 20%
35V
3801 © 4822 051 30563
56kΩ
5% 0,06W
2818 © 3198 024 44730
47nF
5%
50V
3802 © 4822 051 30563
56kΩ
5% 0,06W
2821 © 2238 586 59812
100nF 10%
50V
3803 © 4822 117 12925
47kΩ
1% 0,06W
2822 © 4822 126 13344
1,5nF
5%
63V
3804 © 4822 117 12925
47kΩ
1% 0,06W
2823
4822 124 42383
220µF 20%
4V
3805 © 4822 117 12925
47kΩ
1% 0,06W
2824 ©
2825 ©
2826 ©
2827 ©
2828 ©
4822 126 14043
4822 126 13344
3198 017 34730
5322 126 11578
4822 126 11669
1µF
1,5nF
47nF
1nF
27pF
20%
5%
10%
10%
10%
16V
63V
16V
63V
50V
3806 ©
3807 ©
3808 ©
3809 ©
3810 ©
4822 117 12925
4822 051 30103
4822 051 30103
4822 051 30103
4822 051 30103
47kΩ
10kΩ
10kΩ
10kΩ
10kΩ
1%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2829 ©
2830
2831
2832 ©
2833 ©
3198 017 34730
4822 124 81286
4822 124 81286
3198 017 31530
5322 126 11583
47nF
47µF
47µF
15nF
10nF
10%
20%
20%
10%
10%
16V
16V
16V
50V
63V
3811 ©
3812 ©
3813 ©
3814 ©
3815 ©
4822 051 30103
4822 051 30103
4822 051 30222
4822 051 30222
4822 051 30222
10kΩ
10kΩ
2,2kΩ
2,2kΩ
2,2kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2834 ©
2835 ©
2836
2837 ©
2838 ©
3198 017 31530
5322 126 11583
4822 124 40433
3198 017 34730
3198 017 44740
15nF
10nF
47µF
47nF
470nF
10%
10%
20%
10%
20%
50V
63V
25V
16V
10V
3816 ©
3817 ©
3818 ©
3819 ©
3820 !
4822 051 30222
4822 051 30479
4822 051 30479
4822 051 30479
4822 052 10478
2,2kΩ
47Ω
47Ω
47Ω
4,7Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
NFR25
2839 ©
2840 ©
2841 ©
2843 ©
2844 ©
2238 586 59812
4822 126 14549
2238 586 59812
2020 552 94427
5322 122 33861
100nF
33nF
100nF
100pF
120pF
10%
10%
10%
5%
5%
50V
16V
50V
50V
NP0
3821 ©
3822 ©
3823 ©
3824 ©
3825 ©
4822 117 12917
4822 051 30103
4822 051 30102
4822 051 30474
5322 117 13029
1Ω
10kΩ
1kΩ
470kΩ
47kΩ
5%
5%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
2845 ©
2846
2847 ©
2848 ©
2849 ©
5322 122 33861
4822 124 40248
3198 017 41050
2020 552 94427
5322 122 33861
120pF
10µF
1µF
100pF
120pF
5%
20%
20%
5%
5%
NP0
63V
10V
50V
NP0
3826 ©
3827 ©
3828 ©
3829 ©
3831 ©
4822 117 12891
5322 117 13056
5322 117 13052
4822 051 30121
4822 051 30471
220kΩ
8,2kΩ
2,7kΩ
120Ω
470Ω
1%
1%
1%
5%
5%
0,06W
0,06W
0.06W
0,06W
0,06W
2850 ©
2851
2852 ©
2853 ©
2854
5322 122 33861
4822 124 40248
4822 126 14549
5322 126 11583
4822 124 12245
120pF
10µF
33nF
10nF
220µF
5%
20%
10%
10%
20%
NP0
63V
16V
63V
16V
3832 ©
3833 ©
3834 ©
3836 ©
3837 ©
4822 051 30471
4822 051 30121
4822 051 30472
4822 117 13632
4822 051 30471
470Ω
120Ω
4,7kΩ
100kΩ
470Ω
5%
5%
5%
1%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2855
2860 ©
2861 ©
2863 ©
2864 ©
4822 124 11912
4822 122 33753
4822 122 33753
4822 126 14508
4822 126 14508
220µF
150pF
150pF
180pF
180pF
20%
5%
5%
5%
5%
6,3V
50V
50V
50V
50V
3839 ©
3840 ©
3841 ©
3842 ©
3843 ©
4822 051 30471
4822 051 30223
4822 051 30153
4822 051 30102
4822 051 30102
470Ω
22kΩ
15kΩ
1kΩ
1kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2865 © 4822 126 14508
2866 © 4822 126 14508
180pF
180pF
5%
5%
50V
50V
3844 © 4822 051 30101
3845 © 4822 051 30471
100Ω
470Ω
5%
5%
0,06W
0,06W
10-18
ELECTRICAL
PARTSLIST 5DTC MODULE MP3CD Version CD Board
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3846 © 4822 051 30102
1kΩ
5% 0,06W
3925 © 4822 051 30101
100Ω
5% 0,06W
3847 © 4822 117 12968
820Ω
5% 0,06W
3926 © 4822 051 30101
100Ω
5% 0,06W
3848 © 4822 051 30221
220Ω
5% 0,06W
3927 © 4822 051 30101
100Ω
5% 0,06W
3849 © 4822 051 30471
470Ω
5% 0,06W
3928 © 4822 051 30101
100Ω
5% 0,06W
3850 © 4822 117 12925
47kΩ
1% 0,06W
4807 © 4822 051 30008
CHIP JUMPER 0603
3851 ©
3852 ©
3854 ©
3855 ©
3856 ©
4822 117 12968
4822 051 30221
4822 117 12925
4822 051 30393
4822 051 30472
820Ω
220Ω
47kΩ
39kΩ
4,7kΩ
5%
5%
1%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
4809 ©
4820 ©
4824 ©
4835 ©
4836 ©
4822 051 30008
4822 051 30008
4822 051 30008
4822 051 20008
4822 051 20008
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0805
3857 ©
3859 ©
3860 ©
3861 ©
3862 ©
4822 051 30008
4822 117 13632
4822 051 30123
4822 051 30153
4822 051 30393
CHIP JUMPER 0603
100kΩ
1% 0,06W
12kΩ
5% 0,06W
15kΩ
5% 0,06W
39kΩ
5% 0,06W
4837 ©
4838 ©
4840 ©
4841 ©
4843 ©
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
3864 ©
3865 ©
3866 ©
3867 ©
3868 ©
4822 051 30333
4822 051 30181
4822 117 13608
4822 051 30333
4822 051 30183
33kΩ
180Ω
4,7Ω
33kΩ
18kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1810
2422 540 98519 RESONATOR 8,467MHz
5001 © 2422 549 44607 FERRITE BEAD
5002 © 2422 549 44607 FERRITE BEAD
3869 ©
3870 ©
3871 ©
3872 ©
3873 ©
4822 051 30183
4822 051 30681
4822 051 30181
4822 051 30272
4822 051 30333
18kΩ
680Ω
180Ω
2,7kΩ
33kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6877 © 9322 129 34685 BZX284-C3V9
3874 ©
3875 ©
3876 ©
3877 ©
3878 ©
4822 051 30333
4822 051 30183
4822 051 30183
4822 051 30681
4822 051 30471
33kΩ
18kΩ
18kΩ
680Ω
470Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3879 ©
3880 ©
3881 ©
3883 ©
3884 ©
4822 051 30223
4822 051 30339
4822 051 30151
4822 051 30472
4822 051 30472
22kΩ
33Ω
150Ω
4,7kΩ
4,7kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3888 ©
3889 ©
3890 ©
3891 ©
3892 ©
4822 051 30103
4822 051 30471
4822 051 30471
4822 051 30102
4822 051 30102
10kΩ
470Ω
470Ω
1kΩ
1kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3893 ©
3895 ©
3896 ©
3897 ©
3898 ©
4822 051 30471
4822 051 30273
4822 051 30101
4822 051 30333
4822 051 30221
470Ω
27kΩ
100Ω
33kΩ
220Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3899 ©
3901 ©
3902 ©
3903 ©
3904 ©
4822 051 30272
4822 051 30561
4822 117 11139
4822 051 30332
4822 051 30332
2,7kΩ
560Ω
1,5kΩ
3,3kΩ
3,3kΩ
5%
5%
1%
5%
5%
0,06W
0,06W
0,1W
0,06W
0,06W
3905 ©
3906 ©
3907 ©
3908 ©
3909 ©
4822 051 30681
4822 051 30471
4822 117 12968
4822 051 30222
4822 117 13632
680Ω
470Ω
820Ω
2,2kΩ
100kΩ
5%
5%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
3910 ©
3912 ©
3916 ©
3917 ©
3918 ©
4822 051 30471
4822 051 30221
4822 051 30471
4822 117 13608
4822 051 30103
470Ω
220Ω
470Ω
4,7Ω
10kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3919 © 4822 051 30153
3920 © 4822 051 30101
3923 © 4822 051 30103
15kΩ
100Ω
10kΩ
5%
5%
5%
0,06W
0,06W
0,06W
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7875 © 5322 130 42755 BC847C
7876 © 5322 130 42755 BC847C
7877 © 5322 130 42755 BC847C
7878 © 5322 130 42755 BC847C
7879 © 5322 130 60123 BC807-40
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7800 © 9352 684 20557 SAA7325H/T/M2B, Signal Processor
7801
4822 209 72554 MC7808CT 8V Regulator
7802 © 9322 181 79668 MM1469PH Motor Driver
7810 © 5322 209 82941 LM358D, Dual Opamp
7811 © 5322 209 82941 LM358D, Dual Opamp
10-19
ELECTRICAL
PARTSLIST 5DTC MODULE MP3CD Version Control Board
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MECHANICAL PARTS
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3103 308 54710 5DTC Module (mechanic w/o electronic)
3855 © 4822 117 12706
10kΩ
1% 0,06W
3856 © 4822 117 12706
10kΩ
1% 0,06W
MISCELLANEOUS
3857 © 4822 117 12706
10kΩ
1% 0,06W
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3858 © 4822 051 30102
1kΩ
5% 0,06W
1801
2422 025 17065 FFC-CONNECTOR 16P, top entry
3859 © 4822 051 30103
10kΩ
5% 0,06W
1802
2422 025 17788 FFC-CONNECTOR 8P, top entry
8021
3103 308 93110 FFC-CABLE 16Pin 60mm AD
3860 © 5322 117 13017
100Ω
1% 0,06W
3861 © 2322 704 62002
2kΩ
1% 0,06W
CAPACITORS
3862 © 4822 117 12706
10kΩ
1% 0,06W
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3863
4822 053 10228
2,2Ω
5%
1W
2800 © 4822 126 13879
220nF 20%
16V
4800 © 4822 051 30008
CHIP JUMPER 0603
2801 © 2238 586 59812
100nF 10%
50V
2802 © 2238 586 59812
100nF 10%
50V
4802 © 4822 051 30008
CHIP JUMPER 0603
2803 © 2238 586 59812
100nF 10%
50V
4803 © 4822 051 30008
CHIP JUMPER 0603
2808
4822 124 40433
47µF 20%
25V
4804 © 4822 051 30008
CHIP JUMPER 0603
4805 © 4822 051 20008
CHIP JUMPER 0805
2810 © 3198 017 34730
47nF 10%
16V
4806 © 4822 051 30008
CHIP JUMPER 0603
2811 © 2238 586 59812
100nF 10%
50V
2812 © 2238 586 59812
100nF 10%
50V
4807 © 4822 051 30008
CHIP JUMPER 0603
2813 © 2238 586 59812
100nF 10%
50V
4808 © 4822 051 30008
CHIP JUMPER 0603
2814 © 2238 586 59812
100nF 10%
50V
4809 © 4822 051 20008
CHIP JUMPER 0805
4810 © 4822 051 20008
CHIP JUMPER 0805
RESISTORS
4811 © 4822 051 30008
CHIP JUMPER 0603
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3800 © 4822 051 30472
4,7kΩ
5% 0,06W
4812 © 4822 051 30008
CHIP JUMPER 0603
3801 © 4822 051 30472
4,7kΩ
5% 0,06W
4813 © 4822 051 30008
CHIP JUMPER 0603
3802 © 4822 051 30472
4,7kΩ
5% 0,06W
4814 © 4822 051 30008
CHIP JUMPER 0603
3803 © 4822 051 30472
4,7kΩ
5% 0,06W
4816 © 4822 051 20008
CHIP JUMPER 0805
3804 © 4822 051 30472
4,7kΩ
5% 0,06W
4817 © 4822 051 20008
CHIP JUMPER 0805
3805 ©
3806 ©
3807 ©
3808 ©
3809 ©
4822 051 30472
4822 051 30472
4822 051 30472
4822 051 30472
4822 051 30472
4,7kΩ
4,7kΩ
4,7kΩ
4,7kΩ
4,7kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3810 ©
3811 ©
3815 ©
3816 ©
3818 ©
4822 051 30103
4822 051 30154
5322 117 13057
4822 051 30479
4822 051 30479
10kΩ
150kΩ
820Ω
47Ω
47Ω
5% 0,06W
5% 0,0625W
1% 0,06W
5% 0,06W
5% 0,06W
3819 ©
3820 ©
3821 ©
3823 ©
3824 ©
5322 117 13057
5322 117 13057
4822 051 30479
4822 051 30479
5322 117 13057
820Ω
820Ω
47Ω
47Ω
820Ω
1%
1%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
3826 !
3827 ©
3828 ©
3829 ©
3830 ©
4822 117 12148
4822 051 30101
4822 051 30101
4822 051 30101
4822 051 30103
1,5Ω
100Ω
100Ω
100Ω
10kΩ
5%
5%
5%
5%
5%
0,33W
0,06W
0,06W
0,06W
0,06W
3831 ©
3832 ©
3833 ©
3834 ©
3835 ©
4822 051 30103
4822 051 30272
4822 051 30272
4822 051 30272
4822 051 30272
10kΩ
2,7kΩ
2,7kΩ
2,7kΩ
2,7kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3836 ©
3837 ©
3838 ©
3839 ©
3840 ©
4822 051 30272
4822 051 30272
4822 051 30103
4822 051 30272
4822 051 30272
2,7kΩ
2,7kΩ
10kΩ
2,7kΩ
2,7kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3841 ©
3842 ©
3845 ©
3850 ©
3851 ©
4822 051 30103
4822 051 30103
4822 051 20159
4822 117 12706
4822 117 12706
10kΩ
10kΩ
15Ω
10kΩ
10kΩ
5%
5%
5%
1%
1%
0,06W
0,06W
0,1W
0,06W
0,06W
3852 © 4822 117 12706
3853 © 4822 117 12706
3854 © 4822 117 12706
10kΩ
10kΩ
10kΩ
1%
1%
1%
0,06W
0,06W
0,06W
4818 ©
4819 ©
4820 ©
4821 ©
4822 ©
4822 051 20008
4822 051 30008
4822 051 30008
4822 051 20008
4822 051 20008
CHIP JUMPER 0805
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0805
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1800
4822 242 72066 CERAMIC FILTER 8,0MHz
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7806 © 3198 010 42320 BC857BW
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7800
4822 209 72042 MC78L05ACP, STABILIZER
7801 © 3103 307 01640 TMP87P809M Microcontroller
7803
4822 209 62059 TCA0372DP1, 2-FOLD OP-AMP.
7805
4822 209 62059 TCA0372DP1, 2-FOLD OP-AMP.
10-20
ELECTRICAL
PARTSLIST 5DTC MODULE MP3CD Version MP3 Board
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1451
2422 025 17303 FFC-CONNECTOR 19P,side entry
3484 © 4822 117 12971
15Ω
5% 0,06W
3486 © 4822 051 30101
100Ω
5% 0,06W
CAPACITORS
3488 © 4822 117 13632
100kΩ
1% 0,06W
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3489 © 4822 051 30103
10kΩ
5% 0,06W
2450 © 2238 586 59812
100nF 10%
50V
3490 © 4822 051 30101
100Ω
5% 0,06W
2451 © 3198 017 41050
1µF 20%
10V
2452 © 3198 017 41050
1µF 20%
10V
3491 © 4822 051 30479
47Ω
5% 0,06W
2453 © 2238 586 59812
100nF 10%
50V
3492 © 4822 051 30105
1MΩ
5% 0,06W
2454 © 2238 586 59812
100nF 10%
50V
3493 © 4822 051 30103
10kΩ
5% 0,06W
3494 © 4822 051 30103
10kΩ
5% 0,06W
2455 © 2238 586 59812
100nF 10%
50V
3495 © 4822 051 30103
10kΩ
5% 0,06W
2456 © 2238 586 59812
100nF 10%
50V
2457 © 5322 126 11583
10nF 10%
63V
3497 © 4822 051 30103
10kΩ
5% 0,06W
2458 © 5322 126 11583
10nF 10%
63V
3498 © 4822 051 30332
3,3kΩ
5% 0,06W
2459 © 3198 017 41050
1µF 20%
10V
3499 © 4822 051 30103
10kΩ
5% 0,06W
4450 © 4822 051 30008
CHIP JUMPER 0603
2460 © 2238 586 59812
100nF 10%
50V
2461 © 4822 124 81059
220µF 20%
4V
COILS
2462 © 3198 017 41050
1µF 20%
10V
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2463 © 3198 017 41050
1µF 20%
10V
1460
4822 242 10989 CER.RES. 16,9MHz
2464 © 2238 586 59812
100nF 10%
50V
5450 © 4822 157 11074 100µH
2465 ©
2466 ©
2467 ©
2468 ©
2469 ©
2238 586 59812
2238 586 59812
3198 017 41050
3198 017 41050
2238 586 59812
100nF
100nF
1µF
1µF
100nF
10%
10%
20%
20%
10%
50V
50V
10V
10V
50V
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6450 © 4822 130 11411 BZX284-C3V3
6451 © 4822 130 11366 BZX284-C3V9
7454
4822 130 34174 BZX79-B4V7
2470 © 2238 586 59812
2471 © 2238 586 59812
100nF
100nF
10%
10%
50V
50V
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7452 © 3198 010 42310 BC847BW
7453 © 3198 010 42310 BC847BW
7456 © 3198 010 42310 BC847BW
7460 © 3198 010 42310 BC847BW
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3449 © 4822 051 30101
100Ω
5% 0,06W
3450 © 4822 117 12971
15Ω
5% 0,06W
3451 © 4822 117 12971
15Ω
5% 0,06W
3452 © 4822 051 30101
100Ω
5% 0,06W
3453 © 4822 051 30109
10Ω
5% 0,06W
3454 ©
3455 ©
3456 ©
3457 ©
3458 ©
4822 117 12971
4822 051 30102
4822 051 30102
5322 117 13051
5322 117 13061
15Ω
1kΩ
1kΩ
680Ω
180Ω
5%
5%
5%
1%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
3459 ©
3460 ©
3461 ©
3462 ©
3463 ©
4822 051 30221
4822 051 30102
4822 051 30479
4822 051 30101
4822 051 30101
220Ω
1kΩ
47Ω
100Ω
100Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3464 ©
3465 ©
3466 ©
3467 ©
3468 ©
4822 051 30103
4822 051 30101
4822 051 30471
4822 051 30103
4822 051 30103
10kΩ
100Ω
470Ω
10kΩ
10kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3469 ©
3470 ©
3471 ©
3472 ©
3473 ©
4822 051 30101
4822 117 12971
4822 051 30339
4822 051 30154
4822 117 13632
100Ω
15Ω
33Ω
150kΩ
100kΩ
5%
5%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
3474 ©
3475 ©
3476 ©
3477 ©
3478 ©
4822 117 12971
4822 051 30101
4822 051 30101
4822 051 30471
4822 051 30471
15Ω
100Ω
100Ω
470Ω
470Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3479 ©
3480 ©
3481 ©
3482 ©
3483 ©
4822 051 30471
4822 051 30101
4822 051 30101
4822 051 30471
4822 051 30101
470Ω
100Ω
100Ω
470Ω
100Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7451 © not available
please order complete MP3 Board
7455 © 4822 209 17108 LM317LD Voltage Regulator
7457 © 9352 456 50115 HC1G04, Inverter
7458 © 9322 130 41668 M24C64, EEPROM
3103 308 67020
MP3 Board
11-1
Power 2003 Module
(100W Class D)
TABLE OF CONTENTS
Brief Circuit Description ....................................................................11-2
Service Hints ....................................................................................11-4
COMBI BOARD
Circuit Diagram
Overview .....................................................................................11-7
Source Selector part ...................................................................11-8
Audio Frequency & Logic part.....................................................11-9
Oscillator & Pre-Amplifier part...................................................11-10
Amplifier part Left Channel .......................................................11-11
Amplifier part Right Channel .....................................................11-12
Component Layout
Copperside view .......................................................................11-13
Componentside view.................................................................11-14
MAINS BOARD
Component Layout ...................................................................11-15
Circuit Diagram .........................................................................11-16
Partslist ...........................................................................................11-17
stage M.5/C.2
11-2
Class-D Circuit Description (BASED ON POWER 2003 MODULE -100W CLASS D)
Basically Class-D works by transforming the LF audio input
to a square wave signal with a fixed frequency and a
variable duty cycle. See simplified drawing below.
Required Circuitries:
• 500kHz square wave oscillator.
The oscillator frequency is created by 7312-C; it is a
dual-frequency oscillator with ceramic resonators 5300
and 5302, which resonate at 500kHz and 425kHz
respectively. The resonators are switched by transistors
7309 and 7316, controlled by the "OZ_SW" line from the
port expander 7406.
The reason for 2 frequencies is to avoid tuner
disturbances in the AM-band.
The oscillator signal is shaped to square wave with
7312-B, afterwards buffered and fed to the amplifier
modulators (ROZ to the right channel, LOZ to the left).
One channel gets inverted clock to balance supply
loading.
Modulated Digital Audio Signal
+VL
0
-VL
Duty cycle 9:1
(DC value nearly +VL)
Duty cycle 1:1
(DC value is zero)
Duty cycle 1:9
(DC value nearly -VL)
Amplitude pos. max.
Amplitude zero
+VL
Amplitude neg. max.
0
t
• Modulator
The modulator forms the pulse width modulated signal.
For each channel a seperate modulation is required.
-VL
LF Analog Audio Signal
• Power FETs
The FETs require drivers which supply the gates. One for
the high-side-FET and one for the low-side-FET.
Because of the different supply voltages also an
additional level shifter is necessary per driver.
The amplitude of the square wave signal is equal to the
supply voltage of the amplifier. With the audio signal the
square wave signal is pulse-width modulated.
Compared to a conventional power amplifier the benefits of
the Class D amplifier are:
• higher effiency
• lower power dissipation
• smaller cooling fin
• smaller mains transformer
• Output filter
The output filter is necessary to block the 500kHz square
wave signal from the speaker.
It consists of a series-mode coil 5101 and a capacity of
approx. 550nF (2116, 2134), which forms a Chebycheff
filter with 40kHz cut-off frequency at 6Ω load. For EMC
reasons both, the speaker output and the return ground
are fed through a common mode coil 5102, the filter is
further improved by splitting the output capacity into 2116
before and 2134 after the common mode coil.
Disadvantage of this concept is:
• 500kHz square wave signal with high current requires a
shielding box to suppress radiation.
All above mentioned circuitries are located inside the metal
shielding box.
Blockdiagram Class D
square wave
500kHz
variable duty cycle
+52V
Power-amp.
V1L+7,5V
-45V
V1L+7,5V
+AMP
square wave
500kHz
variable duty cycle
square wave
500kHz
variable duty cycle
analog audio signal
f= 20Hz ...20kHz
+45V
5V
Level
shifter
0V
Analog Pre-amp.
-45V
V1L
OFF
ON
output filter
Modulator
amplified analog audio signal
f= 20Hz ...20kHz
+5V
Level
shifter
OFF
ON
5V
-37V
-37V
0V
square wave
500kHz
duty cycle 1:1
Square wave
Oscillator
-45V
square wave
500kHz
variable duty cycle
-45V
Driver
-45V
-AMP
-39V
-45V
Blockdiagram Class D 2002 04 05
11-3
Class-D Circuit Description (BASED ON POWER 2003 MODULE - 100W CLASS D)
Functional Description:
Protection Circuits:
Refers to the left channel in schematic diagrams.
The first stage of the modulator is an error integrator which
compares the input to the (22 dB amplified) output signal of
the power stage. The difference is leading to a current,
which loads the integrator 7122-A. The second stage
(7122-B) is again integrating, thus creating high gain at low
frequency, which leads to high feedback and low distortion.
The next stage is a comparator, which compares the
integrated voltage to a triangle wave - thus creating a
voltage controlled duty cycle. The comparator is realized by
cascaded gates.
At pin 18 of IC7122 there is a square wave with the same
frequency and duty cycle as the desired output.
The amplifier is protected against low load impedance
(including short circuit). Current is sensed by shunts 3101,
3130 in both supplies. Overcurrent at the positive supply is
then sensed by 7104, the negative supply overcurrent
triggers 7117, which then also triggers 7104. The collector
current then triggers the monoflop 7122-E and -F, giving a
high pulse at pin 10. This shuts off level-shifter 7128 and
triggers transistor 7129, which draws current into the emitter
resistors (3134, 3127) of level-shifter 7119, which is
therefore also shut off. So both FETs are shut off for approx.
0.2 sec, afterwards the amplifier tries to work again, but if
the overload continues the on-time is only a few cycles.
The next task is to feed this information to the output FETs.
Both FETs are n-channel types, so they are modulated by
feeding the gate in respect to the source connection. We
use inverters 74LV14 as drivers. The driver for the low-side
FET (7121) is supplied by the negative supply -VL2 and a
voltage +VL generated by 7115 and 6113, which is 7.5V
higher than -VL2. The digital signal is level-shifted by 7128
to the negative supply reference. 3142, 6111 and 2126
together is a delay circuit for rising edges by approx. 100ns
and 3154,6109 and 2137 for falling edge by 50ns. This is to
compensate the switch-off delay of the FETs and ensures
that both FETs are not conducting at the same time.
The high-side FET (7109) is controlled by the inverted signal
taken from pin 2 of 7118-A, which is level-shifted by
transistor 7119. The driver for the high-side FET is supplied
by a floating voltage between the amplifier output -V1L and
+V1L, created by the charge pump 6110, 2114 regulated by
7114 and 6114 to a 7.5V higher level. The pump is
additionally supplied (via 3151) by +45V to ensure supply at
start-up (no signal). The necessary delay for the rising edge
is generated by the level-shifter (mainly the pull-up 3117)
and the input capacity of the driver (pin 13 of 7105-F).
The last stage in the gate driver consists of three gates in
parallel for increased output current for the capacitive load,
afterwards comes a 47Ω series resistor for soft rising edges
and a transistor for very fast falling edges. This combination
gives the best compromise of efficiency and radiation.
The shut-off mechanism is also used to shut off the amplifier
during headphone usage; this is done by pulling pin 13 of
7122-F high. The line "AMP_OFF" is controlled by the port
expander 7406.
The loudspeakers are protected against DC voltages
resulting e.g. from defective FETs, voltages higher than ±2V
are detected by 7110+7112 and pull down the "DC_PROT"
line, which disables the speaker relay 1201.
The gain of the class-D amplifier is 22dB, adjusted by the
feedback resistors 3135, 3136, 3149 and the input resistors
3139, 3340. The input reference voltage for 7122-A is
approx. half the supply, therefore 3144, 3148 are used for
offset compensation. This compensation can be fine-tuned
by the potentiometer 3306 to reach <1mV DC output.
11-4
Service Hints
The analog part of the Combi Board can be repaired without
opening the metal shielding box. In case of a ‘Class D’
problem it is advised to disassemble the board first,
desolder the metal bottom of the shielding box and
assemble the board again. This takes a few minutes only.
Measuring point A: Output pre-amplifier
Attention: Poor soldering of the metal shielding box results
in disturbance of the tuner.
In most cases the FETs 7109 and/or 7121 for the left
channel, respectively 7218 and/or 7231 for the right channel
will be defective. This can be checked easily with an
ordinary Ohm-meter.
LEFT CHANNEL:
In case 7109 is defect replace following parts:
7109, 7111, 7105, 7119, 7104, 3101, 3103 and 2106
7121, 7113, 7118, 7117,3129, 3130 and 2118
RIGHT CHANNEL:
7218, 7221, 7209, 7228, 7208, 3205, 3209 and 2206
Normal analog signal measured (1kHz- Timebase 1µs). If
this signal can´t be measured - the fault is outside the
shielding box.
Measuring point B: Input Modulator
7231, 7210, 7235, 7227, 3241, 3243 and 2220
If none of the FETs is defective the fault is most probably
located in the modulator. To check the operation - follow the
given signals.
General description of Oscilloscope setup:
Ground Ch1 & Ch2
The 1kHz signal not visible anymore. Reducing the
timebase to 1µs shows the oscillogram below.
Y-Deflection
CH1 = 20V/DIV
Y-Deflection
CH2 = 20V/DIV
Timebase = 1µs
Triggerlevel =-33,6V
Triggered on Ch1
The following signals are measured on condition:
AUX in = 500mV/1kHz, Volume = -28dB
Load = 2 x 6Ω
Measuring point A can be found on circuit diagram 3.
All other measuring points are shown on circiut diagram 4
respectively 5.
11-5
Service Hints
Measuring point C:
Measuring point F: Output modulator
The first stage of the modulator is an integrator. An
integrated rectangle results in a triangle.
In this pulse width modulated square wave the analog Audio
signal is included. Measurements with an analog scope will
show a jitter on the falling edge.
Measuring point D:
The modulator frequency is still fixed to 500kHz. Similar to a
frequency modulation - in this case the amplitude of the
analog audio signal varies the pulse width, the frequency
defines the speed.
Measuring point G:
The oscillator signal (squarewave) is fed to the second
integrator (7122-B).
Measuring point E:
The low-side driver signal (Ch1) is the modulator output
level-shifted by transistor 7128. The high-side driver signal
(Ch2) is the inverted low-side driver signal level-shifted by
transistor 7119.
The integrated rectangle results in a triangle. 7122-C and
7122-F work as a comparator.
11-6
Service Hints
Measuring point H: gate-signal of the FETs
Measuring point I:
Measuring point K:
Digital output signal.
Measuring point J:
The following three signals are measured after output filter
5101 with different timebases.
After common mode coil 5102 - the audio signal is restored.
11-7
11-7
Power 2003 100W Class D
Combi Board Circuit Diagram Overview
SOURCE SELECTOR PART
OSCILLATOR & PRE-AMPLIFIER PART
AMPLIFIER PART
Inputs:
AUX
Tape / USB
Tuner
CD
Generation of following supplies:
+12V
+5V6
+5V_AMP
Modulator
Source Selector IC + sound processing
Pre-Amplifier + mute circuit
Data generation for spectrum analyzer
Adjustment of offset
Digital Out (provisional only)
Square wave Oscillator
LEFT CHANNEL
Driver + Level shifter
Power FETs
4
Protection circuits
Chapter 11-11
Overvoltage protection for:
+AMP
-AMP
+5V6
+12V_A
AMPLIFIER PART
RIGHT CHANNEL
Modulator
Driver + Level shifter
Power FETs
3
Chapter 11-10
5
Protection circuits
Speaker relay
Chapter 11-12
AUDIO FREQUENCY & LOGIC PART
p
Headphone Amplifier
Subwoofer out (provisional only)
Control Lines
Port Expander (shift register)
1
Chapter 11-8
Generation of +5V_CD
Fan control
Signal flow
2
Chapter 11-9
P2003 Class D Drawing Overview 2002 12 17
11-8
E3
F3
F11
F3
G4
G4
G5
G5
2564
2565
2566
2567
2568
2569
2570
2571
4
G5
G5
G6
G6
G12
G8
G10
G11
2572
2573
2574
2575
2576
2577
2578
2581
5
H9
H10
H9
H9
H7
H8
H7
E13
2582
3500
3504
3506
3507
3514
3515
3517
6
D12
A2
A3
E12
F12
A3
A13
A14
3518
3519
3520
3521
3522
3523
3524
3525
A2
A3
A3
A11
A2
B2
B9
B3
7
3526
3527
3528
3529
3530
3531
3532
3533
B10
B3
B11
B9
B13
B9
B10
C2
8
3534
3535
3536
3539
3542
3543
3544
3545
C5
C8
D8
D8
D7
D9
D10
E3
9
10
15K
3520
1u
470p
2528
10K
4K7
+12V_A 3
5K6
3536
33n
3539
10 11
4,5V TU_L 6
SW_INFO
TAPE_R
100R
3563
4,5V TAPE_R 24
CD_SH_DATA
CD_R
3564
100R
4,5V CD_R 25
11
CD_SH_CLK
AUX_R
100R
3568
4,5V AUX_R 26
REC
14 4,8V
13
VOLUME I
TREBLE
BASS
VOLUME II
RIGHT
RIGHT
RIGHT
RIGHT
SUR.
VOL_RIGHT
2 3
17 4,5V 3566
100R
+5V6
+5V6
9
8301
-VKK
10
F1
11
1u
1u
2581
100n
6508
BZX384-C5V6
CD_SH_CLK
F2
12
CD_SH_DATA
13
CD_SH_DATA
NTC_
4.5V
GND_D
SW_INFO
SICL
GND_D
15
SW_INFO
16
GND_D
GND_D
0.5V
3570
NTC_BASE
SILD
17
DATA
18
SILD
7509
BC847BW
19
RAB
FE-BT-VK-N
1012
TU_STEREO
1
TU_CLK
2
TU_DATA
3
TU_ENAB
4
TU_STEREO
PROTECTION CIRCUIT
5K6
3579
5
I2C_DATA
I2C_CLK
For 5DTC
pin1 to 4 are not used
TU_CLK
SA_IN
6
POWER_DOWN
7
5 AMP_CLIP
8
9
LOW_PWR_CTRL
TU_ENAB/MPX
GND_D
SA_IN
POWER_DOWN
CLIP
LOW_PWR_CTRL
A
Power2003 100W Class D Combi-Source Selector Part 2003 02 10
1
G
DATA
RAB
TU_DATA
3n3
2578
FE-BT-VK-N
2
3
4
5
6
7
8
9
10
11
F
14
1
GND_D
E
8
2575
8K2
I2C_CLK
GND_D
6
F2
330n
3578
I2C_DATA
SICL
2571
3573
470R
2570
100p
2573
470n
2572
220n
4n7
2574
470n
15K
3577
4
F1
33n
SHIELD
SHIELD
1n
2577
COAX1
2576
12K
3576
4
5K6
3575
100R
5
2
2569
3574
3571
SICL
22K
SILD
SICL
1V
BAS316
4,5V
4,5V
3
I2C_CLK
CD_SH_CLK
6505
19 18
4,5V
NTC
I2C_DATA
100K
20
4,5V
1026
1
7
+5V6
+12V_A
1V
47u
22 21
D
-Vkk
FE-BT-VK-N
3 +5V6
0V
0,8V
LINE_R
+5V6
2568
470p
2567
470p
2566
470p
2565
470p
2564
DATA
470p
2563
9
IIC BUS
100R
470p
2562
RAB
F2
1
-VKK
+AMP
15 4,4V
LOGIC
2
12
PWR_DWN
4
2
-AMP
0V
16 4,5V
4,5V TU_R 23
13
10
SOURCE
SELECTOR
BXZX384-C47
6502
4,5V TAPE_L 5
100R
BASS ALC
6506
8K2
BAS316
3554
3557
NTC
+5V6_CON
3507
1K8
100R
TU_L
3560
5.6V
1K8
3559
4,5V CD_L 4
100R
BC857B
7506
3555
100R
TAPE_L
TU_R
100R
3558
LEFT
3561
+12V_M 3
4,5V AUX_L 3
LOW_PWR_CTRL
5
C
GND_D
1K
LEFT
3562
LEFT
28
3552
5V6 ECO
6
3
+5V5_CON
12K
LEFT
SUR.
VOL_LEFT
2 3
4,5V 3551
12
3556
VOLUME II
6504
BASS
BAS316
TREBLE
6507
3111
15
2559
3553
CD_L
CD_R
1u
+5V_CD 2
3
+D2
2
3506
4K7
VOLUME I
3K3
2557
AUX_L
7
COAX1
9
+D2
5
5.6V
BAS316
9
1K
8
3567
3132
1u
GND_D
COAX2
+D
470R
1K
2K2
16
6
-AMP
7
NTC_
4,5V
4,5V
3569
17
8
6
+5V5_CON
+5V6
4,5V
Overvoltage Protection
3131
2582
5K6
3544
2552
4,5V
POWER
SUPPLY
GND_D
H
3528
2539
2549
BXZX384-C47
18
CD_L
DATA
SILD
470R
82K
3532
2548
470n
2K2
470p
2561
RAB
+D
-VKK
6503
4,5V 27
VREF
CD_SH_DATA
CD_SH_CLK
3
15K
470n
2558
BZX384-C2V7
2556
470p
SW_INFO
19
14
-AMP
8
22K
330n
9V 1
47u
1u
6501
2555
10R
TU_L
1
3118
6K8
GND_D
+11V_D
5
F1
8K2
3n3
12K
3542
3534
+12V_A
3
0,8V
7508
TDA7468D 7
22u
2553
2560
G
FROM/TO CD Changer Module
+5V_CD
8
7
4n7
TU_R
1u
6K8
CD_RIGHT
B
5
4 -AMP_L
14
9
1018
GND_A
7500-C
5.6V
GND_A
3550
+12V_A 3
FE-BT-VK-N
CD_LEFT
+AMP
4
100R
2
TU_LEFT
+AMP
F1
3543
TU_ENAB
39K
3549
LINE_L
2543
2551
39K
3545
3
GND_A
7
LOW_PWR
_SUPPLY 7
220n
TU_CLK
TU_DATA
4
TU_RIGHT
5
6
LOW_PWR_CTRL
shield
NTC_
COAX1
POWER_DOWN
SA_IN
F2
2550
BZX79-C10
3533
7
6
2541
FROM/TO TUNER
TU_STEREO
5
+11V_A
14
5
2
470n
for provision only
8
TU_ENAB/MPX
1
4 +AMP_L
TAPE_R
1u
1013
TU_DATA
1010
100n
EH-B
-VKK
TU_CLK
7500-B
10
1210
2537
4K7
D
TAPE Supply
1
for provision only
2533
1011
-CMOS
TU_STEREO
1020
1u
3124
FE-BT-VK-N
A
2
6RG
7
1
10
1n
7
TAPE_L
YKC21-3416
3 +12V_M
4
3
3123
39K for S
3535
6
-CMOS
2540
3
4
39R
7500-D
6n8 for S
2546
TP_RIGHT
4u7 LINE_R
2542
5
2535
6500
+11V_A
7505
BC847BW
100n
4u7 LINE_L
6
27K
GND_A
5K6
TAPE / USB
4
2534
COAX
DIGITAL
OUT
2
3
2536
150K 3531
1006
100n
2
7
7500-E
330K
3526
LINE_R 150K 3529
LINE_L
11
2527
1
14
100n
100n
2519
Spectrum Analyzer
3517
5500
100n
3
2K2
14
3524
LINE_L
27K
7500-A
3521
3523
3525
2
B10
E12
E7
G14
E13
F14
15
3
7
AUX_R
1K5
2
1
12
74HCU04D
1K2
3527
14
2529
3 +12V_A
7505
7506
7508
7509
7510
8301
2532
15K
13
D13
E13
A12
B12
B12
C12
B11
A11
14
150p
AUX IN
3519
1K5
1
3
13
6508
6510
7500-A
7500-B
7500-C
7500-D
7500-E
7500-F
+5V6
7
7500-F
3518
1022
GND_A
C3
C5
F14
G13
G13
G12
F12
F12
220R
3
TP_LEFT
6500
6501
6502
6503
6504
6505
6506
6507
3515
14
LINE_R
TP_REC_RIGHT
H6
H8
H7
H8
H9
H10
D13
A13
12
AUX_L
B
TP_REC_LEFT
3574
3575
3576
3577
3578
3579
4501
5500
2526
1u
3514
10K
470p
1K5
2520
2500
1K5
G11
G12
G6
G12
G13
G8
G10
G11
for provision only
3504
3522
3566
3567
3568
3569
3570
3571
3572
3573
11
2
1
F6
F13
F14
F6
G12
G13
G6
G6
DIGITAL OUT
3500
1005
F
3557
3558
3559
3560
3561
3562
3563
3564
SOURCE SELECTOR PART
4
E
E6
E3
E10
F6
F6
F6
F13
F13
COMBI BOARD
A
C
3549
3550
3551
3552
3553
3554
3555
3556
0201
3
2556
2557
2558
2559
2560
2561
2562
2563
FROM / TO MAINS BOARD
D10
D10
D8
D9
E8
E3
E2
E6
FROM/TO FRONT
2
2548
2549
2550
2551
2552
2553
2554
2555
12
13
14
15
FROM / TO FRONT
B3
B13
C11
C3
D6
D7
D8
D8
3572
470R
1
2537
2538
2539
2540
2541
2542
2543
2546
3530
1
A3
A12
A2
A13
B13
B3
B3
B9
560R
2528
2529
2531
2532
2533
2534
2535
2536
1n
B1
D15
C1
A3
A1
A2
A13
A14
2538
1022
1026
1311
2500
2519
2520
2526
2527
100p
A1
A15
B15
C15
G15
D1
F1
A15
2531
1005
1006
1010
1011
1012
1013
1018
1020
11-8
2
H
11-9
1004 E1
1014 G1
1400 D13
1401 E9
2400 B3
2401 C3
2402 B5
2403 C1
2408 D1
2409 D3
2410 D5
2411 E3
2404 C3
2405 C4
2406 D1
2407 D3
1
2
2412 E4
2413 E1
2414 F2
2415 E8
2420 H5
2421 H14
3400 B3
3401 C3
2416 D8
2417 F4
2418 H2
2419 H2
2
11-9
3406 C4
3407 D2
3408 D2
3409 D2
3402 C5
3403 C2
3404 C2
3405 C2
3
3415 E3
3418 E2
3419 F2
3420 F3
3410 D5
3411 D7
3412 D8
3413 D3
4
5
3421 F3
3422 F4
3423 F5
3424 G2
3429 G5
3430 G5
3431 G9
3432 G3
3425 G4
3426 G4
3427 G11
3428 G11
6
3433 G4
3434 G10
3435 H14
3436 H5
7
3437 H8
3438 H10
3439 H5
3440 H7
6400 D8
6401 G14
6402 H8
7400-A D3
8
7400-B C3
7402 D8
7403 F3
7404 F2
7405 F4
7406 F12
7407 G2
7408 G3
9
7409 G9
7410 G4
7411 H8
8302 E12
9268 G8
10
11
12
13
14
COMBI BOARD
AUDIO FREQUENCY & LOGIC PART
A
A
3400
HEADPHONE AMPLIFIER
27K
2400
B
B
100p
Fan runs permanently.
Higher volume increases the speed.
6405
BAS316
AMP_RIGHT
FAN_CONT
5
100u
5.2V
4
4K7
6403
2410
2
BZX384-C3V3
3K3
3410
D
11.5V
8.2V..11V
7402
BC337-40
3411
7.5V..10.3V
3418
2
470p
2K2
100u
2412
2415
E
AMP_MUTE 3
PORT EXPANDER
D6
D7
3434
2K2
8
REG SO
SHIFT
4
D5
13 3
2
+5V6
+5V
+5V
16
+5V6
6401
4.1V
I2C_DATA
10K
A
Power2003 100W Class D Combi-Audio Frequency Part 2003 02 10
1
2
3
4
5
G
1N4148
CS0
H
4K7
4.1V
CS1
15
GND_D
3439 MUTE_HP
4.1V = MUTE
4.8V = ACTIVE
14
CS2
100n
+5V
4.8V
1u
H
0.7V
3438
7410
BC857BW
5 AMP_RELAIS
0V
7409
BC817-25W(COL)
2420
3436
4.8V
5K6
3431
1K
MUTE
for 3DTC versions only
for 5DTC versions a wire bridge is stuffed instead of 6402
D4
3435
3.9V
6402
3 OZ_SW
D3
270R
3430
0.8V
3433
BC817-25
7408
1K
100p
2419
2418
FE-BT-VK-N
0.8V
3432
BC817-25
7407
1
+5V6
2421
3429
HP_LEFT
3440
+5V_CD
1N4148
CHIP SELECT
2
BC807-25W(COL)
7411 4.7V
TRANSCEIVER
I 2 C BUS
GND_A
2R2
D2
SDA
4.4V
39R
D1
I2C_CLK
39R
10K
3426
3428
3425
10K
3
10K
39R
5K6
39R
3437
4
3427
MUTE_HP
D0
F
1
I/O PORT
8
8
8
DATA LATCHES
OUT I/O
IN
8
8
8
HP_DET
5
HP_DET
6
MUTE_SW
10K
7
1014
4 AMP_OFF
3423 MUTE_SW
10K
3424
4.6V
AMP_OFF
12 11 10 9
4K7
1u
2K2
7406
M62320FP
SCL
4.8V
+5V
MUTE
GND RES
PWR
VDD
7405
BC857BW
2417
3422
+5V
7404
BC817-25
3421
1
FAN
3420
100p
FROM/TO HP SOCKET BOARD
G
-
SUB_W
2414
2K2
3419
3
F
HP_RIGHT
+
2
470R
7403
BC817-25
HP_DET
1401
1
EH-B
1004 1
YKC21-3416
100p
3415 27K
100n
OUT
SUBWOOFER
E
22u
2411
2413
2416
GND_A
provisional
1u
2407
100p
7400-A
NJM4556AM
1
3
470p
470R
1u
2409
6K8
3408
3409
3413
2408
C
2
+12V_M
+12V_A
3
5R6
3K3
FAN CONTROL
3412
4u7
2405
10R
3402
100p
2404
27K
3403
6K8
3404
5K6
3405
3406
AMP_LEFT
100u
GND_A
4K7
3407
470u
5.2V
2406
1 VOL_RIGHT
8
7
7400-B
NJM4556AM
11.5V
27K
from Source Selector 7506
D
+12V_A
V_MID
3
5
470R
1u
2402
5.2V
470p
2403
1 VOL_LEFT
C
3401
2401
6
6
7
8
9
10
11
12
13
14
11-10
1
3
2
3
4
5
6
8
9
10
11
12
SUPPLY, OSCILLATOR & PRE-AMPLIFIER PART
3
C
1n
2313
1M
3318
425K
CSBLA
220p
5302
2314
5.2V 3340
2330
2580
22u
22u
3325
A
3337
2328
2224
22u
22u
470R
2
7320-A
NJM4560
2K2
A
100n
G
5
RNF
+5V6
3319
2 AMP_MUTE
7324
2K2
BC817-25
100n
5.2V
150K
1
2336
4u7
3339
Adjust to
0V ±1mV DC on Speaker Terminal
12K
3326
1K
2329
470p
3338
2325
V_MID
2
100n
2322
47u
2321
100p
2333
120R
3342
470R
100p
3336
3
VOL_RIGHT
1
BC817-25
2335
7323
2327
1 2 3
F
+5V6
3329
2 AMP_MUTE
3306
7320-B
NJM4560
150K
4
470R
6
LNF
3307
7
4
3316
2317
8
47K
4u7
E
47K
5
10K
1K
8K2
PRE - AMPLIFIER
33R
10K
VOL_LEFT
1
3K3
+12V_A
3330
1
4K7
3580
6300
3334
LOW_PWR_CTRL
4u7
2331
2332
10K
4.7V
470p
2.2V
100p
3328
2318
BZX384-C3V3
33K
3332
27K
3314
47K
3322
2326
470R
3344
3345
100n
2320
H
4.2V
3327
3317
100p
BC847BW
0V
+5V6
3343
5
7312-F
D
150R
4.35V
ROZ
12
2K2
A
G
13
BC857BW
7316
100K
2324
O
4
4.2V
0V
5.6V
I
7312-D
3324
7321
LM317P
10.9V
8
0V
1 2 3 5
0.65V
9
7312-E
11.5V
7319
BC847BW
10
LOZ
2303
F
1 +D2
11
4
7312-B
47u
2304
2316
100n
1K
3321
6
7312-C
1 2
820R
10u
7317
3323
3346
47R
10.45V
2337
5
0V
+D
220R
3313
100n
+12V_A
2
6K8
10u
11.7V
O
B
3341
14
7312-A
7312 = 74HCU04D
3331
+12V_M
7309
BC847BW
7
1K
3315
7315
LM317P
2312
2301
A
470p
OZ_SW = H -> 425kHz
OZ_SW = L -> 500kHz
E
CSBLA
500K
4.25V
2
OZ_SW
A
2300
100K
10K
3303
1u
2305
10K
C
I
220p
3302
3311
2
100K
1 +D
5300
3
3312 4.1V 1
22.9V
220p
10K
1u0
10u
2339
6K8
3305
R
K
2309
1
+5V_AMP
3 4 5
A
TL431CLP-RM
7310
OSCILLATOR
33p
3320
4.25V
22R
100n
2319
100n
Bead
100MHz
2306
+5V6
2334
+5V_AMP
3304
B
D
7
COMBI BOARD
5104
A
11-10
H
2224 G11
2300 A7
2301 A9
2303 B6
2304 D3
2305 B5
2306 A2
2309 B3
2312 E1
2313 C6
2314 D9
2316 D2
2317 E10
2318 F8
2319 A1
2320 H1
2321 G3
2322 G3
2324 E7
2325 G8
2326 E9
2327 F9
2328 G11
2329 G7
2330 E11
2331 E7
2332 F7
2333 G7
2334 A10
2335 F12
2336 H12
2337 F1
2580 E11
3302 B7
3303 B5
3306 G12
3307 H12
3311 A3
3312 B6
3313 D2
3314 E3
3315 C5
3316 F8
3318 C7
3319 H10
3320 B10
3321 E2
3322 E4
3323 F2
3324 C8
3325 F12
3326 G12
3327 D10
3328 E9
3329 F10
3330 F11
3331 H11
3332 E8
3334 E7
3336 G9
3337 G10
3338 G7
3339 G8
3340 E10
3341 B8
3342 G2
3343 G2
3344 G2
3345 H2
3346 E1
3347 G6
3580 F4
4301 A5
5104 A2
5300 A8
5302 D8
6300 E4
7309 B9
7310 A3
7312-A C6
7312-B C9
7312-C B8
7312-D C11
7312-E C10
7312-F D10
7315 D1
7316 C9
7317 E3
7319 E3
7320-A G9
7320-B F9
7321 F2
7323 F11
7324 H11
9284 H4
9288 G4
Power2003 Class D Combi-Supply, Osc & Pre-Amp Part 2003 02 07
1
2
3
4
5
6
7
8
9
10
11
12
⁄ for wave forms see chapter 11-4 Service Hints
Attention:
Adjustment to 0V ±1mV has to be done with ‘cold’ set.
After operating a few minutes the value may increase up to 30mV.
11-11
2100 A10
2101 A11
2102 A9
2103 A9
2104 A2
2118 F10
2119 F2
2120 D1
2121 D4
2122 C10
2113 D8
2114 D9
2115 E13
2116 E11
2117 E13
2106 B11
2108 A5
2110 D8
2111 C3
2112 D10
1
4
2
3107 D7
3108 A2
3109 B9
3110 B5
3114 A5
3100 A2
3101 B10
3102 B2
3103 B10
3106 B11
2132 C4
2134 E13
2135 F3
2136 F10
2137 B7
2124 F10
2125 E1
2126 F7
2128 G10
2130 G10
11-11
3
3122 C4
3125 F3
3126 A1
3127 C2
3128 E12
3115 E5
3117 B6
3119 D8
3120 C3
3121 C3
4
5
3148 F2
3149 F2
3151 C9
3152 C9
3153 D9
3142 F7
3143 E5
3144 F2
3146 F5
3147 B1
3136 E11
3137 E12
3139 E2
3140 E3
3141 C10
3129 F10
3130 F10
3133 D7
3134 D6
3135 E9
6
5101 D11
5102 D12
5103 F10
6106 D8
6108 C4
3154 B7
3155 E11
4101 E12
4102 E12
5100 A10
7
8
7114 C8
7115 C4
7117 F11
7118-A F5
7118-B F6
7105-E B7
7105-F B6
7109 B10
7111 C9
7113 E9
7104 B11
7105-A C8
7105-B B8
7105-C B8
7105-D B8
6109 B7
6110 D10
6111 F7
6113 D4
6114 E8
9
7121 E10
7122-A E2
7122-B E3
7122-C E3
7122-D E4
7118-C F7
7118-D E8
7118-E F8
7118-F F8
7119 D7
10
7122-E A4
7122-F A5
7128 E5
7129 B2
7130 A3
11
COMBI BOARD
7131 C2
9201 D12
9202 E12
9272 A1
12
13
+AMP_L
AMPLIFIER PART LEFT CHANNEL
3108
Driver Stage + Levelshifter
0V
SC_L
4
2137
3147
5
2102
330u
6
7105-C
BAS316
3154
11
B
1K0
10
7109
3109
STP14NF12FP
7105-E
7105-F
3
46.2V
3102
BC856B
7104
3103
H2
1K0
Amplifier ON-OFF Switch
4K7
0V
BC856B
7129
12
SC_L
4
7105 = 74LV14
33p
6109
13
G2
0.5V
10K
8
7105-D
4K7
7122 = 74HCU04D
B
9
45V
4R7
4
7105-B
22K
F
14
+V1L
3114
1n0
4.2V
13
100n
3101
12
A
100n
2100
0R047
11
E
0V
7122-F
1K8
10
10n
7122-E
0V
3117
10n
6.3V
3110
0.7V
2104
3126
10K
10K
AMP ON = H = 4V
AMP OFF = L = 0V
7130
BC847BW
2108
3100
100n
+V1L
100K
9272
2103
0V
2 AMP_OFF
Power Stage
BEAD 100MHz
3106
A
2101
5100
AMP_D
5
4K7
2106
4.2V
3 +5V_AMP
2.5V
-44.4V
BAV99
3141
22R
1
3
I
D
8
2.1V
0.4V
3143
4n7
BC856B
7128
4K7
3149
3
7118-B
4
3142
5
2115
1n
1n
220n
2117
2134
10K
4K7
3155
10K
3137
3
4
HF2024
9202
LS_L_neg
5
BC807-25
6
-VL2
MBTA42
7117
3129
1K0
100p
-43.8V
LOZ
3
12
2136
7
-VL
100n
330u
7118 = 74LV14
2124
-VL
-45V
100n
-AMP
1
G
F
1n0
7118-F
BAS316
2126
1K5
-37.6V
13
-VL
G
Power2003 100W Class D Combi-Amplifier Part left channel 2003 02 10
1
2
3
E
4102
7118-C
1K2
6111
3146
F
7118-A
2
1K
3125
470p
7113
7118-E
G1
5
10
5103
4n7
7122 = 74HCU04D
-40.7V 1
LS_L
1
-45V
0V
11
2135
STP14NF12FP
4R7
B
2119
4101
3136
6 9
2118
C
5102
2130
5
2.1V
2
30uH
-45V
7121
3135
7118-D
100n
4
8
3130
B
1K0
9
0R047
3
1K2 2.1V
H1
14
7122-D
1K
2
1.9V
3140
7122-C
BEAD 100MHz
7
7122-B
+VL
9201
5101
0VDC
330n
3128
2
45V
F
D
K
Output Filter
2128
A
E
J
Supply
High-Side Driver
1u0
6114
BAV99 3
2116
1
6110
20V
2113
1.2V
2
2K2
22K
12
3119
10u
BZX384-C6V8
8V
4K7
5K6
1K5
3107
330R
3133
3134
-45V
3115
D
4.2V
14
470R
2125
1u
2110
2121
1u0
-VL2
2
18K
3148
150K
3144
C
2.1V 1
3139
3 LNF
2K2
3153
-V1L
7122-A
E
6.3V = supply for 7105
MBTA42
7119
1u
2120
3
3152
+V1L
--43.8V
C
220p
1u
BC817-25
Supply Low-Side Driver
+5V_AMP
2122
220p
7114
-VL
D
MODULATOR
7
-V1L
1
BAV99
6113
3
3151
7105-A
2132
6108
3122
GND_SHIELD
BZX384-C6V8
-45V
2
100K
1u0
8K2
2111
8K2
3121
3120
1
-36.8V
22K
7111
BC807-25
-37.5V
-37.5V
10K
3127
C
+VL
2114
-25V
7131
BC846B
6106
-44.8V
7115
BC817-25
4
5
6
7
8
9
10
11
12
13
11-12
2200 A10
2201 A9
2202 A11
2203 A8
2205 A13
2206 B10
2214 D8
2215 D12
2216 E11
2217 C9
2218 F9
2219 E12
2208 A4
2209 C11
2210 C7
2211 C3
2212 D10
2213 G9
1
2
3215 B9
3216 B10
3217 A4
3218 B2
3219 C12
3221 C1
3205 B9
3207 A12
3209 B9
3210 A4
3211 E5
3213 F2
3
3223 C12
3224 C12
3225 B5
3226 C11
3227 B1
3228 D8
4
3229 D13
3230 C2
3231 C3
3232 C3
3238 E11
3239 C10
5
3240 E11
3241 F9
3243 F9
3245 D6
3246 D5
3247 E8
3256 F5
3258 G1
3259 G1
3261 D6
3262 F14
3263 G13
3248 E10
3251 E1
3252 E2
3253 F6
3254 F1
3255 E4
6
3264 C8
3265 C8
3266 C8
3267 B6
3268 D10
4201 E11
4202 E11
5200 A10
5201 D11
5202 D12
5203 G9
5205 C11
7
8
9
7227 F10
7228 D6
7231 E9
7232-A E1
7232-B E2
7232-C E3
7211 B12
7218 B9
7220 C12
7221 C8
7222 C8
7223 B4
7209-B B7
7209-C A7
7209-D B6
7209-E B5
7209-F A7
7210 E9
10
11
7243 G14
9203 D12
9204 E12
7235-D E8
7235-E E8
7235-F F8
7238 B2
7239 B2
7240 E5
7232-D E4
7232-E A3
7232-F A4
7235-A F5
7235-B F5
7235-C E7
12
13
14
COMBI BOARD
1
+AMP
AMPLIFIER PART RIGHT CHANNEL
H2
4
7209-A
Only for DARC feature
6 9
8
D
2.1V
2.1V
2.1V
3255
B
11
3253
2
13
47u
3
1307-A
1n
2215
10K
10K
3240
4K7
2234
1n
4
2
E
3
6
4
1
OSA-SS
4
6216
1N4148
-AMP
BEAD 100MHz
2229
5203
2225
-AMP
1
BC847BW
7110
0V
3112
-45V
-VR
-VR
Output-DC-Protection
0R047
100n
330u
7235 = 74LV14
-43.8V
3243
100p
2227
2218
100n
3256
1K0
7
-VR
-37.6V
3
3241
12
BAS316
2220
6217
4
+12V_A
3
47K
100n
4
2213
3
7235-B
4K7
3259
ROZ
3
G
2
3
4
MBTA42
7227
7235-F
-40.7V
7235-A
1K
3213
1
G1
4n7
1K5
GND_SHIELD
F
10K
3248
-VR2
1K2
470p
3229
BAV99
1
2214
6
5
3
5
L_PROT
10
5
1
9204
7235-C
0V
2
BC807-25
7210
7235-E
2237
2221
2
2
4202
-45V
0.4V
BC856B
7240
1201
4
1307-B
C
1
3263
470K
3116
-45V
6104
BAS316
F
DC_PROT
5 7203
0.7V
3262
5
4201
1
100R
4
1
1212 1211
LS_L
1K2
B
1K0
BAV99
D
LS_L_neg
1.9V
3
4n7
7
3252
8
-45V
4R7
7232-D
6206
2
3113
2
A
7232-C
3
HF2024
22K
470R
14
9
F
E
7232-B
4
47u
2.1V 1
D
7231
STP14NF12FP
3247
2
1
2109
3251
RNF
3
H1
1K
C
4.2V
C
5
L_PROT
FAN_CONT
2
5202
30uH
45V
6210
14
3211
18K
150K
3258
1u
7232 = 74HCU04D
1
9203
4K7
BAV99
3268
5K6
1K5
3245
-V1R
BAV99
K
5201
0VDC
+VR
3254
2222
2
7235-D
E
2226
3261
330R
6205
Output Filter
1
1.2V
BZX384
C4V7
J
I
1u0
1.2V
3246
MODULATOR
2239
3
330n
3238
MBTA42
7228
Supply
High-Side
Driver
2216
-45V
20V
10u
-VR2
Supply Low-Side Driver
2
2K2
1n0
D
22K
6212
2
3228
8V
6211
1u
BZX384-C6V8
1u0
2238
2210
1
BAV99
6208
3
2K2
3266
+V1R
6209
--43.8V
330K
6K8
2209
220p
3265
3223
3224
1
AMP_CLIP 4u7
68K
BC817-25
7222
-VR
BC857BW
7220
5205
2217
3226
47n
-V1R
18K
22R
1u
FAN CONTROL
3219
7221
BC807-25
3239
6213
3232
2236
BZX384-C6V8
22K
-45V
C
2
7
220p
1
2212
1u0
2211
8K2
8K2
3231
3230
10K
7209 = 74LV14
-37.5V
-36.8V
1
+AMP
STP14NF12FP
-37.5V
B
SC_R
5
4R7
+VR
BAS316
3
46.2V
BC817-25
7223
-25V
6202
BC857BW
7211
1K0
45V
7218
7209-D
3215
7238
BC846B
7232-A
7208
3209
1K0
7209-E
-44.8V
3221
3
8
22K
B
9
2219
G2
BAS316
3267
10
220n
11
47K
470K
3216
4K7
-44.4V
2201
7209-B
Amplifier ON-OFF Switch
3218
0V
A
3201
0V
3207
BC856B
6214
3264
10K
Output-DC-Protection
7203
BC847BW
33p
1n0
100K
7232 = 74HCU04D
0.7V
DC_PROT
5
3262
100n
2240
BC856B
0.5V 7239
3227
6
22K
7232-F
5
2206
7232-E
Driver Stage + Levelshifter
0R047
7
SC_R
5
4K7
3205
0V
100n
BEAD 100MHz
2200
14
330u
F
4.2V
+V1R
3225
E
0V
+V1R
7209-C
3210
13
3217
A
12
11
2202
5200
100n
14
10
+45V
Power Stage
2203
4.2V
AMP_D
4
10n
2208
+5V_AMP
3203
2205
0V
+5V_AMP
3
6217 F6
7110 F12
7112 G12
7203 A13
7208 B10
7209-A C7
6210 D8
6211 C9
6212 D8
6213 C4
6214 B6
6216 F14
6104 G12
6202 B13
6205 C13
6206 C13
6208 D3
6209 C12
100K
5
2240 A6
3112 F11
3113 F12
3116 G12
3201 A14
3203 A13
2229 G9
2234 D12
2236 C4
2237 F3
2238 D4
2239 D8
2220 F10
2221 F2
2222 E1
2225 F9
2226 E1
2227 F7
1K8
1201 E14
1211 D13
1212 D13
1307-A D14
1307-B E14
2109 F11
11-12
AMP_RELAIS
2
7243
BC817-25
10K
7112
BC857BW
G
Power2003 100W Class D Combi-Amplifier Part right channel 2003 02 10
1
2
3
4
5
6
7
8
9
10
11
12
13
14
11-16
2215 D5
2216 E8
2217 E9
2218 E1
2219 E7
2226 D7
2228 C1
2230 A7
2231 B7
2232 A7
2233 A7
3200 A8
3201 B8
3202 A8
3203 B9
3204 A2
3205 B9
3206 B2
3207 C8
3211 D4
4
3
33K
0u47
2205
3K9
6204
BZX79-C33
3205
680R
3203
2208
100u
PWR_DWN 5.3V
F2
3
F1
2
-Vkk
1
BZX79-F8V2
470R
3213
F2
F1
-Vkk
-33.4V
6226
0201
+AMP
1
+AMP
+45V
2
+AMP
+45V
5
-AMP
-45V
-AMP
6
-AMP
-45V
+D
7
+D
22.9V
+D2
9
+D2
10.9V
xxV
PLAY MODE
xxV
ECO STANDBY MODE
220u
2217
5.6V
6222
BZX79-C5V6
10u
6221
1N4148
6219
1N4148
100n
2215
4
3
4
8
xxV
measured with a " not grounded multimeter "
10
1N4003
Power2003 100W ClassD Mains Board Circuit Diagram 2003 02 07
1
2
3
4
5
6
7
8
9
10
TO COMBI BOARD 1010 1
1N4003
6220
330R
1mH
3A1631N
2n2
6223
6225
19V
3220
3215
5203
100R
E
NTC
5V6_ECO
10n
BC557B
7204
5
C
D
1N4148
2224
BZX79-C39
BD438
41V
MAINS_2
38V
680R
6
2219
47n
3
100K
1mH
3222
3219
2220
22n
2218
5202
6216
5.6V
LOW_PWR_CTRL
NTC
13.3V
1
7203
6215
6
5V6_ECO
100n
4
7206
BC547B
1N4148
7
PWR_DWN
12V_RELAIS
1N4148
2226
5
2216
4M7
3212
100u
2213
3211
470n
220n
2222
2214
330R
6217
D
5204
2
LOW_PWR_CTRL
100n
2223
100n
1210
5V6_ECO
FROM / TO COMBI BOARD 1011 1
STANDBY
330R
100u
2207
1N4003
MAINS_1
2201
2225
3221
6201
4n7
0V
6213
B
PWR_DWN
4K7
T2A
19372
1N4003
-Vkk
-34V
4K7
1N4148
3m3
100n
2211
2210
3207
4.7V
1N5392
+D
LOW_PWR_CTRL
1N4148
6200
3223
6229
1208
1209
6227
-33.4V
5.3V
22.9V
1N4148
7200
BD438
33K
3202
3300u
2233
1N5392
19372
MAINS_2
6211
12V_RELAIS
100n
1207
6207
2
-46V
4R7 1N4003
6m8
F2
2212
15
6210
2K2
10.2V
3217
1N4148
6228
22u
2228
C
16
OZ
0.7V
10
-AMP
+D2
T2A
1
1N4148
9201 B3
A
10.9V
F1
2000TS-092
3
10K
3218
5
6224
2231
8
4
6212
9
3201
1N5392
7
8
6
+D2
7203 D3
7204 E5
7205 B2
7206 D5
9200 A3
+AMP
9
T.F
7
0V
2200
10
6
B
-45V
5
10M
9201
11 DISPLAY
T5A
19372
4m7
4
T1A6 /21 ONLY
T1A25 NON ECO
MAINS_1
6226 E2
6227 B8
6228 C1
6229 C8
7200 A9
1212
1N5392
3
3206
3200
13
3300u
2
12
1205
MAINS_2
6221 E8
6222 E8
6223 E3
6224 C1
6225 E2
3
9200
/21 ONLY
6215 D8
6216 D9
6217 D2
6219 D6
6220 D8
8
45V
6202
4m7
2232
14
GBU8D
2204
1
NOT /21
SDKP
7205
BC337-40
BZX79-B2V7
NTC
1
5
10M
17
2
6
1223
3204
A
1220
4
97TS
T5A
19372
5001
T1A6 IEC
T4A UL
T1A25 NON ECO
1206
/37 ONLY
1
6209 C6
6210 C7
6211 C3
6212 C3
6213 D2
7
2230
1201
1222
6201 C9
6202 A6
6204 B9
6206 C6
6207 C7
1203
2203
1221
5001 A4
5202 E1
5203 E1
5204 D7
6200 B8
6
NTC
5220
2
3219 E6
3220 E4
3221 D6
3222 E3
3223 B8
5
MAINS BOARD / P2003 100W CLASS D
1204
3212 D5
3213 D8
3215 E3
3217 C2
3218 B1
6206
2
2220 E1
2222 D1
2223 D6
2224 E6
2225 C8
100n
1
2210 C7
2211 C7
2212 B7
2213 D4
2214 D1
6209
2204 A6
2205 A10
2207 B8
2208 B9
2209 C6
100n
1222 A2
1223 A2
2200 A6
2201 C8
2203 A6
2209
1207 B5
1208 C3
1209 C5
1210 C10
1212 B5
100n
0201 D10
1201 A3
1203 A5
1205 A3
1206 A3
11-16
E
11-17
ELECTRICAL
PARTSLIST POWER 2003 100W Class-D MAINS BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MISCELLANEOUS
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1201 ! 4822 071 51602 FUSE 1,6A
5202
4822 157 53473 1000µH
1201 ! 4822 253 10126 FUSE T4A
5203
4822 157 53473 1000µH
1203 ! 4822 071 55002 FUSE T5A
5220 ! 4822 157 11832 400µH Mains filter
1204 ! 2422 030 00328 MAINS SOCKET /37
1204 ! 4822 265 31015 MAINS SOCKET, IEC
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
1205 ! 4822 071 51602 FUSE 1,6A
6200
4822 130 30621 1N4148
1206 ! 2422 129 16478 VOLTAGE SELECTOR
6201
4822 130 34382 BZX79-B8V2
1207 ! 9965 000 07788 FUSE RAD T2A
6202
4822 130 11139 GBU8D
1208 ! 2422 132 07519 RELAY 1P 12V 16A
6204
4822 130 34142 BZX79-B33
1209 ! 9965 000 07788 FUSE RAD T2A
6206
4822 130 31878 1N4003G
1210
1212 !
5001 !
5001 !
5001 !
4822 267 10953
4822 071 55002
3103 308 30920
3103 308 30910
3103 308 30900
5204 ! 2422 549 45157
FFC-CONNECTOR, 7P, TOP ENTRY
FUSE T5A
Mains Transformer /37
Mains Transformer /22
Mains Transformer /21, /21M
6207
6209
6210
6211
6212
4822 130 31878
4822 130 31878
4822 130 31878
4822 130 30621
4822 130 30621
1N4003G
1N4003G
1N4003G
1N4148
1N4148
STANDBY TRANSFORMER
6213
6215
6216
6217
6219
4822 130 31878
4822 130 30621
4822 130 30621
4822 130 31878
4822 130 30621
1N4003G
1N4148
1N4148
1N4003G
1N4148
6220
6221
6223
6224
6225
4822 130 31983
4822 130 31983
4822 130 34145
5322 130 34563
4822 130 31878
BAT85
BAT85
BZX79-B39
BZX79-C2V7
1N4003G
6226
6227
6228
6229
4822 130 31878
4822 130 31878
4822 130 30621
4822 130 30621
1N4003G
1N4003G
1N4148
1N4148
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2200
4822 121 43696
100nF 10%
100V
2201
4822 122 31125
4,7nF 10%
63V
2203
4822 121 43696
100nF 10%
100V
2204
4822 121 43696
100nF 10%
100V
2205
5322 124 41948 0,47µF 20%
50V
2208
2209
2210
2211
2212
2020 012 93547
5322 121 42386
5322 121 42386
4822 124 42367
4822 124 12328
100µF
100nF
100nF
3300µF
6800µF
20%
5%
5%
20%
20%
63V
63V
63V
35V
16V
2213
2214 !
2215
2216
2217
4822 124 40255
4822 121 10512
5322 121 42386
4822 124 21732
4822 124 80144
100µF
220nF
100nF
10µF
220µF
20%
20%
5%
20%
20%
50V
275V
63V
25V
25V
2218
2219 !
2220
2222 !
2223
4822 121 41856
4822 126 14088
4822 121 43526
4822 126 13589
5322 121 42386
22nF
2,2nF
47nF
470nF
100nF
5%
20%
5%
10%
5%
250V
250V
100V
275V
63V
2224
2225
2226
2228 ©
2232
4822 122 30043
5322 121 42386
5322 121 42386
4822 124 11946
2022 020 00644
10nF
100nF
100nF
22µF
3300µF
80%
5%
5%
20%
20%
63V
63V
63V
16V
50V
2233
2022 020 00644
3300µF
20%
50V
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3200
4822 050 23303
33kΩ
1%
0,6W
3201 ! 4822 052 10478
4,7Ω
5% NFR25
3202
4822 050 23303
33kΩ
1%
0,6W
3203
4822 116 52276
3,9kΩ
5%
0,5W
3204 ! 4822 053 21106
10MΩ
5%
0,5W
3205
3206 !
3207
3211
3212
4822 116 52228
4822 053 21106
4822 116 52283
4822 116 52219
4822 111 30893
680Ω
10MΩ
4,7kΩ
330Ω
4,7MΩ
5%
5%
5%
5%
5%
0,5W
0,5W
0,5W
0,5W
0,2W
3213
3215
3217
3218
3219
4822 116 83883
4822 116 52175
4822 116 52256
4822 050 21003
4822 116 52234
470Ω
100Ω
2,2kΩ
10kΩ
100kΩ
5%
5%
5%
2%
5%
0,16W
0,5W
0,16W
0,25W
0,5W
3220
3221
3222
3223
4822 116 52219
4822 116 52219
4822 116 52228
4822 116 52283
330Ω
330Ω
680Ω
4,7kΩ
5%
5%
5%
5%
0,5W
0,5W
0,5W
0,5W
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7200
4822 130 40995 BD438
7203
4822 130 40995 BD438
7204
4822 130 44568 BC557B
7205
4822 130 40855 BC337-40
7206
4822 130 40959 BC547B
11-18
ELECTRICAL
PARTSLIST POWER 2003 100W Class-D COMBI BOARD
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
MECHANICAL PARTS
CAPACITORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
0021
4822 492 11735 SPRING TRANSISTOR
2219 © 5322 126 11578
1nF 10%
63V
2220 © 5322 126 11578
1nF 10%
63V
MISCELLANEOUS
2221 © 4822 126 13193
4,7nF 10%
63V
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2222 © 3198 017 41050
1µF 20%
10V
1005
2422 026 05418 SOCKET, CINCH, 2p
2224
4822 124 81151
22µF 20%
50V
1011
4822 267 10953 FFC-CONNECTOR, 7P, TOP ENTRY
1012
2225
2020 012 93762
330µF 20%
50V
1013
2226 © 4822 126 13193
4,7nF 10%
63V
1014
4822 267 10733 FFC SOCKET, 4P
2227 © 2020 552 94427
100pF
5%
50V
2229 © 2222 580 15649
100nF 10%
50V
1018
2234
4822 121 42408
220nF
5%
63V
1022
1026
4822 265 11553 FLEX FOIL CONNECTOR 19P
2236 © 3198 017 41050
1µF 20%
10V
1201
2422 132 07517 RELAY 2P 12V
2237 © 4822 126 13881
470pF
5%
50V
1307
2422 015 19893 SOCKET, CLICKFIT, 4P
2238 © 3198 017 41050
1µF 20%
10V
2239 © 3198 017 41050
1µF 20%
10V
CAPACITORS
2240 © 2222 867 15339
33pF
5%
50V
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2100 © 4822 122 33496
100nF 10%
63V
2300 © 4822 126 13883
220pF
5%
50V
2101 © 2222 580 15649
100nF 10%
50V
2301 © 4822 126 13883
220pF
5%
50V
2102
2020 012 93762
330µF 20%
50V
2303 © 4822 126 13881
470pF
5%
50V
2103 © 2222 580 15649
100nF 10%
50V
2304
4822 124 81286
47µF 20%
16V
2104 © 5322 126 11583
10nF 10%
63V
2305 © 3198 017 41050
1µF 20%
10V
2106 ©
2108 ©
2109
2110 ©
2111
5322 126 11578
5322 126 11583
4822 124 81286
3198 017 41050
4822 124 22651
1nF
10nF
47µF
1µF
1µF
10%
10%
20%
20%
20%
63V
63V
16V
10V
50V
2306 ©
2309
2312 ©
2313 ©
2314 ©
4822 126 14585
4822 124 11947
2222 580 15649
3198 016 31020
4822 126 13883
100nF
10µF
100nF
1nF
220pF
10%
20%
10%
5%
5%
50V
16V
50V
25V
50V
2112 ©
2113 ©
2114
2115 ©
2116
4822 122 33575
3198 017 41050
4822 124 40248
5322 126 11578
5322 121 42661
220pF
1µF
10µF
1nF
330nF
5%
20%
20%
10%
5%
50V
10V
63V
63V
63V
2316 ©
2317
2318 ©
2319 ©
2320 ©
4822 126 14585
4822 124 21732
4822 126 13881
4822 126 14585
4822 126 14585
100nF
10µF
470pF
100nF
100nF
10%
20%
5%
10%
10%
50V
25V
50V
50V
50V
2117 ©
2118 ©
2119 ©
2120 ©
2121 ©
5322 126 11578
5322 126 11578
4822 126 13193
3198 017 41050
3198 017 41050
1nF
1nF
4,7nF
1µF
1µF
10%
10%
10%
20%
20%
63V
63V
63V
10V
10V
2321
2322 ©
2324
2325 ©
2326 ©
4822 124 81286
4822 126 14585
4822 124 22726
4822 126 13881
2020 552 94427
47µF
100nF
4,7µF
470pF
100pF
20%
10%
20%
5%
5%
16V
50V
35V
50V
50V
2122 ©
2124
2125 ©
2126 ©
2128 ©
4822 122 33575
2020 012 93762
4822 126 13193
2020 552 94427
2222 580 15649
220pF
330µF
4,7nF
100pF
100nF
5%
20%
10%
5%
10%
50V
50V
63V
50V
50V
2327 ©
2328
2329
2330
2331
2020 552 94427
4822 124 81151
4822 124 22726
4822 124 81151
4822 124 22726
100pF
22µF
4,7µF
22µF
4,7µF
5%
20%
20%
20%
20%
50V
50V
35V
50V
35V
2130 ©
2132 ©
2134
2135 ©
2136 ©
2222 580 15649
3198 017 41050
4822 121 42408
4822 126 13881
2222 580 15649
100nF
1µF
220nF
470pF
100nF
10%
20%
5%
5%
10%
50V
10V
63V
50V
50V
2332 ©
2333 ©
2334 ©
2335 ©
2336 ©
2020 552 94427
2020 552 94427
2222 867 15339
2238 586 59812
2238 586 59812
100pF
100pF
33pF
100nF
100nF
5%
5%
5%
10%
10%
50V
50V
50V
50V
50V
2137 ©
2200 ©
2201
2202 ©
2203 ©
2222 867 15339
2222 580 15649
2020 012 93762
2222 580 15649
2222 580 15649
33pF
100nF
330µF
100nF
100nF
5%
10%
20%
10%
10%
50V
50V
50V
50V
50V
2337
2339 ©
2400 ©
2401 ©
2402
4822 124 21732
3198 017 41050
2020 552 94427
4822 126 13881
4822 124 23052
10µF
1µF
100pF
470pF
100µF
20%
20%
5%
5%
20%
25V
10V
50V
50V
16V
2205
2206 ©
2208 ©
2210 ©
2211
4822 124 81286
5322 126 11578
5322 126 11583
3198 017 41050
4822 124 22651
47µF
1nF
10nF
1µF
1µF
20%
10%
10%
20%
20%
16V
63V
63V
10V
50V
2403
2404 ©
2405
2406
2407 ©
4822 124 22651
2020 552 94427
4822 124 12032
4822 124 80791
2020 552 94427
1µF
100pF
4,7µF
470µF
100pF
20%
5%
20%
20%
5%
50V
50V
50V
16V
50V
2212 ©
2213 ©
2214
2215 ©
2216
4822 122 33575
2222 580 15649
4822 124 40248
5322 126 11578
5322 121 42661
220pF
100nF
10µF
1nF
330nF
5%
10%
20%
10%
5%
50V
50V
63V
63V
63V
2408
2409 ©
2410
2411 ©
2415 ©
4822 124 22651
4822 126 13881
4822 124 23052
2020 552 94427
3198 017 41050
1µF
470pF
100µF
100pF
1µF
20%
5%
20%
5%
20%
50V
50V
16V
50V
10V
2217 © 4822 122 33575
2218 © 2222 580 15649
220pF
100nF
5%
10%
50V
50V
2416
4822 124 23052
2417 © 3198 017 41050
100µF
1µF
20%
20%
16V
10V
11-19
ELECTRICAL
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
CAPACITORS
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
2418 © 2020 552 94427
100pF
5%
50V
3111 © 4822 051 30682
6,8kΩ
5% 0,06W
2419 © 2020 552 94427
100pF
5%
50V
3112 © 4822 117 12925
47kΩ
1% 0,06W
2420 © 3198 017 41050
1µF 20%
10V
3113 © 4822 051 30223
22kΩ
5% 0,06W
2421 © 2238 586 59812
100nF 10%
50V
3114 © 4822 051 30472
4,7kΩ
5% 0,06W
2500
2022 020 00734
1µF 20%
50V
3115 © 4822 051 30102
1kΩ
5% 0,06W
2519 ©
2520 ©
2528
2531 ©
2534
2238 586 59812
4822 126 13881
2022 020 00734
4822 126 13881
4822 124 40769
100nF
470pF
1µF
470pF
4,7µF
10%
5%
20%
5%
20%
50V
50V
50V
50V
100V
3116 ©
3117 ©
3118 ©
3119 ©
3120 ©
4822 051 30474
4822 117 12903
4822 051 30682
4822 051 30103
4822 117 12902
470kΩ
1,8kΩ
6,8kΩ
10kΩ
8,2kΩ
5%
1%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
2535
2536 ©
2537
2540
2541
4822 124 40769
2238 586 59812
2022 020 00734
2022 020 00734
4822 124 81151
4,7µF
100nF
1µF
1µF
22µF
20%
10%
20%
20%
20%
100V
50V
50V
50V
50V
3121 ©
3122 ©
3123 ©
3124 ©
3125 ©
4822 117 12902
4822 051 30223
4822 051 30472
4822 051 30472
4822 051 30102
8,2kΩ
22kΩ
4,7kΩ
4,7kΩ
1kΩ
1%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2542 ©
2543 ©
2546 ©
2548 ©
2549 ©
3198 016 31020
2020 552 96684
4822 126 14549
2020 552 96327
2020 552 96684
1nF
470nF
33nF
330nF
470nF
5%
10%
10%
10%
10%
25V
25V
16V
16V
25V
3126 ©
3127 ©
3128 ©
3129 ©
3130 ©
4822 051 30103
4822 051 30103
4822 051 30103
4822 051 30102
2122 118 06235
2550 ©
2551 ©
2552 ©
2553
2555
5322 126 11579
4822 126 13879
4822 126 13193
4822 124 22651
4822 124 81286
3,3nF
220nF
4,7nF
1µF
47µF
10%
20%
10%
20%
20%
63V
16V
63V
50V
16V
3131 ©
3132 ©
3133 ©
3134 ©
3135 ©
4822 051 30222
4822 051 30222
4822 051 30562
4822 051 30331
4822 117 13608
2,2kΩ
2,2kΩ
5,6kΩ
330Ω
4,7Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2556
2557
2558 ©
2559
2560 ©
4822 124 22651
2022 020 00734
2020 552 96684
2022 020 00734
4822 126 13881
1µF
1µF
470nF
1µF
470pF
20%
20%
10%
20%
5%
50V
50V
25V
50V
50V
3136 ©
3137 ©
3139
3140 ©
3141 ©
4822 051 30472
4822 051 30103
4822 116 83883
4822 117 11817
4822 117 12139
4,7kΩ
10kΩ
470Ω
1,2kΩ
22Ω
5%
5%
5%
1%
5%
0,06W
0,06W
0,16W
0,06W
0,06W
2561 ©
2562 ©
2563 ©
2564 ©
2565 ©
4822 126 13881
4822 126 13881
4822 126 13881
4822 126 13881
4822 126 13881
470pF
470pF
470pF
470pF
470pF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
3142 ©
3143 ©
3144 ©
3146 ©
3147 ©
4822 117 11817
4822 051 30102
4822 051 30154
4822 051 30152
4822 051 30103
1,2kΩ
1kΩ
150kΩ
1,5kΩ
10kΩ
1%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2566 ©
2567 ©
2568
2569 ©
2570 ©
4822 126 13881
4822 126 13881
4822 124 12233
2020 552 96684
2020 552 94427
470pF
470pF
47µF
470nF
100pF
5%
5%
20%
10%
5%
50V
50V
25V
25V
50V
3148 ©
3149 ©
3151 ©
3152 ©
3153 ©
4822 051 30183
4822 051 30472
4822 117 13632
4822 051 30222
4822 051 30222
18kΩ
4,7kΩ
100kΩ
2,2kΩ
2,2kΩ
5%
5%
1%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2571 ©
2572 ©
2573 ©
2574 ©
2575 ©
2020 552 94427
4822 126 13879
2020 552 96684
4822 126 13193
2020 552 96327
100pF
220nF
470nF
4,7nF
330nF
5%
20%
10%
10%
10%
50V
16V
25V
63V
16V
3154 ©
3155 ©
3201 ©
3203 ©
3205 ©
4822 051 30102
4822 051 30472
4822 117 12925
4822 051 30223
2122 118 06235
1kΩ
5% 0,06W
4,7kΩ
5% 0,06W
47kΩ
1% 0,06W
22kΩ
5% 0,06W
CHIP JUMPER 2512
2576 ©
2577 ©
2578 ©
2580
2581
3198 016 31020
4822 126 14549
5322 126 11579
4822 124 81151
4822 124 22651
1nF
33nF
3,3nF
22µF
1µF
5%
10%
10%
20%
20%
25V
16V
63V
50V
50V
3207 ©
3209 ©
3210 ©
3211 ©
3213 ©
4822 051 30474
4822 051 30102
4822 051 30472
4822 051 30102
4822 051 30102
470kΩ
1kΩ
4,7kΩ
1kΩ
1kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
2582 © 2238 586 59812
100nF
10%
50V
3215 ©
3216 ©
3217 ©
3218 ©
3221 ©
4822 117 13608
4822 051 30223
4822 117 13632
4822 051 30472
4822 051 30103
4,7Ω
22kΩ
100kΩ
4,7kΩ
10kΩ
5%
5%
1%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3225 ©
3227 ©
3228 ©
3229 ©
3230 ©
4822 117 12903
4822 051 30103
4822 051 30103
4822 051 30103
4822 117 12902
1,8kΩ
10kΩ
10kΩ
10kΩ
8,2kΩ
1%
5%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
0,06W
3231 © 4822 117 12902
3232 © 4822 051 30223
8,2kΩ
22kΩ
1%
5%
0,06W
0,06W
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3100
4822 050 21003
10kΩ
2% 0,25W
3101 © 2122 118 06235 CHIP JUMPER 2512
3102 © 4822 051 30472
4,7kΩ
5% 0,06W
3103 © 4822 051 30102
1kΩ
5% 0,06W
3106 © 4822 051 30223
22kΩ
5% 0,06W
3107 ©
3108 ©
3109 ©
3110 ©
4822 051 30152
4822 051 30472
4822 117 13608
4822 117 13632
1,5kΩ
4,7kΩ
4,7Ω
100kΩ
5%
5%
5%
1%
0,06W
0,06W
0,06W
0,06W
10kΩ
5% 0,06W
10kΩ
5% 0,06W
10kΩ
5% 0,06W
1kΩ
5% 0,06W
CHIP JUMPER 2512
11-20
ELECTRICAL
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS
RESISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3238 © 4822 051 30103
10kΩ
5% 0,06W
3344 © 4822 051 30471
470Ω
5% 0,06W
3239 © 4822 117 12139
22Ω
5% 0,06W
3345 © 4822 051 30471
470Ω
5% 0,06W
3240 © 4822 051 30103
10kΩ
5% 0,06W
3346 © 4822 051 30479
47Ω
5% 0,06W
3241 © 4822 051 30102
1kΩ
5% 0,06W
3400 © 4822 051 30273
27kΩ
5% 0,06W
3243 © 2122 118 06235 CHIP JUMPER 2512
3401 © 4822 051 30471
470Ω
5% 0,06W
3245 ©
3246 ©
3247 ©
3248 ©
3251
4822 051 30562
4822 051 30331
4822 117 13608
4822 051 30472
4822 116 83883
5,6kΩ
330Ω
4,7Ω
4,7kΩ
470Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,16W
3403 ©
3404 ©
3405 ©
3406 !
3407 ©
4822 051 30273
4822 051 30682
4822 051 30472
4822 052 10109
4822 051 30472
27kΩ
6,8kΩ
4,7kΩ
10Ω
4,7kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
NFR
0,06W
3252 ©
3253 ©
3254 ©
3255 ©
3256 ©
4822 117 11817
4822 117 11817
4822 051 30154
4822 051 30102
4822 051 30152
1,2kΩ
1,2kΩ
150kΩ
1kΩ
1,5kΩ
1%
1%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3408 ©
3409 ©
3411
3412 !
3413 ©
4822 051 30682
4822 051 30273
4822 116 52283
4822 052 10568
4822 051 30471
6,8kΩ
27kΩ
4,7kΩ
5,6Ω
470Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,5W
0,33W
0,06W
3258 ©
3259 ©
3261 ©
3262 ©
3263 ©
4822 051 30183
4822 051 30472
4822 051 30152
4822 051 30101
4822 051 30103
18kΩ
4,7kΩ
1,5kΩ
100Ω
10kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3415 ©
3422 ©
3423 ©
3424 ©
3425 ©
4822 051 30273
4822 051 30472
4822 051 30103
4822 051 30103
2120 108 91909
27kΩ
4,7kΩ
10kΩ
10kΩ
39Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
3264 ©
3265 ©
3266 ©
3267 ©
3268 ©
4822 117 13632
4822 051 30222
4822 051 30222
4822 051 30102
4822 051 30472
100kΩ
2,2kΩ
2,2kΩ
1kΩ
4,7kΩ
1%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3426 ©
3427 ©
3428 ©
3429 ©
3430 ©
2120 108 91909
4822 051 30103
4822 051 30103
2120 108 91909
2120 108 91909
39Ω
10kΩ
10kΩ
39Ω
39Ω
5%
5%
5%
5%
5%
3302 ©
3303 ©
3304
3305 ©
3306
4822 117 13632
4822 051 30103
4822 116 52186
4822 051 30682
4822 101 11778
100kΩ
1% 0,06W
10kΩ
5% 0,06W
22Ω
5%
0,5W
6,8kΩ
5% 0,06W
Potmeter 47kΩ 0,1W
3431 ©
3432 ©
3433 ©
3434 ©
3435 ©
4822 051 30562
4822 051 30102
4822 051 30102
4822 051 30222
4822 051 30271
5,6kΩ
1kΩ
1kΩ
2,2kΩ
270Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3307
3311 ©
3312 ©
3313 ©
3314 ©
4822 101 11778
4822 051 30103
4822 117 13632
4822 051 30221
4822 117 12925
Potmeter 47kΩ
10kΩ
5%
100kΩ
1%
220Ω
5%
47kΩ
1%
0,1W
0,06W
0,06W
0,06W
0,06W
3436 ©
3437 ©
3438 ©
3439 ©
3440
4822 051 30472
4822 051 30562
4822 051 30103
4822 051 30103
4822 116 81154
4,7kΩ
5,6kΩ
10kΩ
10kΩ
2,2Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,5W
3315
3316 ©
3317 ©
3318 ©
3319 ©
4822 050 11002
4822 051 30273
4822 051 30333
4822 117 13632
4822 051 30222
1kΩ
27kΩ
33kΩ
100kΩ
2,2kΩ
5%
5%
5%
1%
5%
0,2W
0,06W
0,06W
0,06W
0,06W
3500 ©
3504 ©
3506 ©
3507 ©
3514 ©
4822 051 30152
4822 051 30103
4822 051 30471
4822 117 12902
4822 051 30153
1,5kΩ
10kΩ
470Ω
8,2kΩ
15kΩ
5%
5%
5%
1%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3320 ©
3321 ©
3322 ©
3323 ©
3324 ©
4822 051 30103
4822 051 30102
4822 051 30103
4822 117 12968
4822 051 30105
10kΩ
1kΩ
10kΩ
820Ω
1MΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3518 ©
3519 ©
3520 ©
3522 ©
3523 ©
4822 051 30152
4822 051 30103
4822 051 30153
4822 051 30152
4822 051 30152
1,5kΩ
10kΩ
15kΩ
1,5kΩ
1,5kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3325 ©
3326 ©
3327
3328 ©
3329
4822 051 30154
4822 051 30154
4822 052 10339
4822 117 12902
4822 116 52256
150kΩ
150kΩ
33Ω
8,2kΩ
2,2kΩ
5%
5%
5%
1%
5%
0,06W
0,06W
NFR
0,06W
0,16W
3524 ©
3525 ©
3526 ©
3527 ©
3529 ©
4822 117 11817
4822 051 30273
4822 051 30334
4822 051 30273
4822 051 30154
1,2kΩ
27kΩ
330kΩ
27kΩ
150kΩ
1%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3330 ©
3331 ©
3332 ©
3334 ©
3336 ©
4822 051 30103
4822 051 30103
4822 051 30332
4822 051 30102
4822 051 30123
10kΩ
10kΩ
3,3kΩ
1kΩ
12kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3531 ©
3532 ©
3534
3535 ©
3536 ©
4822 051 30154
4822 117 12864
4822 052 10109
4822 051 30562
4822 051 30223
150kΩ
82kΩ
10Ω
5,6kΩ
22kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
NFR
0,06W
0,06W
3337 ©
3338 ©
3339 ©
3340 ©
3341 ©
4822 051 30471
4822 051 30102
4822 051 30222
4822 051 30471
4822 051 30682
470Ω
1kΩ
2,2kΩ
470Ω
6,8kΩ
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3539 ©
3542 ©
3543 ©
3544 ©
3545 ©
4822 051 30153
4822 051 30123
4822 117 12902
4822 051 30562
4822 051 30393
15kΩ
12kΩ
8,2kΩ
5,6kΩ
39kΩ
5%
5%
1%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3342 © 4822 051 30121
3343 © 4822 051 30151
120Ω
150Ω
5%
5%
0,06W
0,06W
3549 © 4822 051 30101
3550 © 4822 051 30393
100Ω
39kΩ
5%
5%
0,06W
0,06W
0,06W
0,06W
11-21
ELECTRICAL
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
RESISTORS
COILS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
–––––––––––––––––––––––––––––––––––––––––––––––––––––
3551 © 4822 051 30101
100Ω
5% 0,06W
5100
4822 526 10494 FERRITE BEAD
3552 © 4822 051 30101
100Ω
5% 0,06W
5101
2422 536 00612 30µH
3553 © 4822 051 30101
100Ω
5% 0,06W
5102
2422 549 44944 Mains Filter 330µH 3A
3554 © 4822 051 30101
100Ω
5% 0,06W
5103
3555 © 4822 051 30472
4,7kΩ
5% 0,06W
5104
3556 ©
3557 ©
3558 ©
3559 ©
3560 ©
4822 051 30123
4822 051 30101
4822 117 12903
4822 117 12903
4822 051 30101
12kΩ
100Ω
1,8kΩ
1,8kΩ
100Ω
5%
5%
1%
1%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
5200
5201
5202
5203
5300
4822 526 10494
2422 536 00612
2422 549 44944
4822 526 10494
2422 540 98542
FERRITE BEAD
30µH
Mains Filter 330µH 3A
FERRITE BEAD
Resonator 500kHz
3561 ©
3562 ©
3563 ©
3564 ©
3566 ©
4822 051 30102
4822 051 30102
4822 051 30101
4822 051 30101
4822 051 30101
1kΩ
1kΩ
100Ω
100Ω
100Ω
5%
5%
5%
5%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
5302
2422 540 98561
Resonator 425kHz
3567 ©
3568 ©
3569 ©
3570 ©
3571 ©
4822 051 30332
4822 051 30101
4822 051 30102
4822 117 13632
4822 051 30223
3,3kΩ
100Ω
1kΩ
100kΩ
22kΩ
5%
5%
5%
1%
5%
0,06W
0,06W
0,06W
0,06W
0,06W
3572
3573
3574 ©
3575 ©
3576 ©
4822 116 83883
4822 116 83883
4822 051 30101
4822 051 30562
4822 051 30123
470Ω
470Ω
100Ω
5,6kΩ
12kΩ
5%
5%
5%
5%
5%
0,16W
0,16W
0,06W
0,06W
0,06W
3577 ©
3578 ©
3579 ©
3580 ©
4101 ©
4822 051 30153
4822 117 12902
4822 051 30562
4822 051 30472
4822 051 20008
15kΩ
5% 0,06W
8,2kΩ
1% 0,06W
5,6kΩ
5% 0,06W
4,7kΩ
5% 0,06W
CHIP JUMPER 0805
4102 ©
4201 ©
4202 ©
4211 ©
4212 ©
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
4822 051 20008
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0805
4213 ©
4214 ©
4215 ©
4216 ©
4217 ©
4822 051 30008
4822 051 20008
4822 051 30008
4822 051 30008
4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
4221 ©
4223 ©
4226 ©
4230 ©
4232 ©
4822 051 30008
4822 051 30008
4822 051 30008
4822 051 30008
4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
4233 ©
4235 ©
4240 ©
4241 ©
4242 ©
4822 051 30008
4822 051 30008
4822 051 20008
4822 051 20008
4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0805
CHIP JUMPER 0603
4243 ©
4245 ©
4253 ©
4260 ©
4265 ©
4822 051 30008
4822 051 30008
4822 051 30008
4822 051 20008
4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0603
4272 ©
4273 ©
4274 ©
4276 ©
4277 ©
4822 051 30008
4822 051 30008
4822 051 20008
4822 051 30008
4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0603
CHIP JUMPER 0805
CHIP JUMPER 0603
CHIP JUMPER 0603
4279 © 4822 051 30008
4301 © 4822 051 30008
CHIP JUMPER 0603
CHIP JUMPER 0603
DIODES
–––––––––––––––––––––––––––––––––––––––––––––––––––––
6104 © 4822 130 11397 BAS316
6105 © 4822 130 11397 BAS316
6106 © 4822 130 11416 PDZ6.8B
6108 © 4822 130 11416 PDZ6.8B
6109 © 4822 130 11397 BAS316
6110 ©
6111 ©
6113 ©
6114 ©
6202 ©
5322 130 34337
4822 130 11397
5322 130 34337
5322 130 34337
4822 130 11397
BAV99
BAS316
BAV99
BAV99
BAS316
6205 ©
6206 ©
6208 ©
6210 ©
6211 ©
5322 130 34337
5322 130 34337
5322 130 34337
5322 130 34337
5322 130 34337
BAV99
BAV99
BAV99
BAV99
BAV99
6212 ©
6213 ©
6214 ©
6216
6217 ©
4822 130 11416
4822 130 11416
4822 130 11397
4822 130 30621
4822 130 11397
PDZ6.8B
PDZ6.8B
BAS316
1N4148
BAS316
6300 ©
6401
6403 ©
6501 ©
6502 ©
4822 130 10838
4822 130 30621
4822 130 10838
9322 102 64685
4822 130 11397
UDZ3.3B
1N4148
UDZ3.3B
UDZ-2,7B
BAS316
6503 ©
6504 ©
6505 ©
6506 ©
6507 ©
4822 130 11397
4822 130 11397
4822 130 11397
9322 150 18685
9322 150 18685
BAS316
BAS316
BAS316
BZX384-C47
BZX384-C47
6508 © 3198 020 55680
BZX384-C5V6
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7104 © 4822 130 60373 BC856B
7109 ! 9322 173 29687 STP14NF12FP Power FET
7110 © 3198 010 42310 BC847BW
7111 © 3198 010 44350 BC807-25W
7112 © 3198 010 42320 BC857BW
7113 ©
7114 ©
7115 ©
7117 ©!
7119 ©
3198 010 44350
9340 219 30115
9340 219 30115
9322 043 49685
9322 043 49685
BC807-25W
BC817-25W
BC817-25W
MMBTA42
MMBTA42
7121 !
7128 ©
7129 ©
7130 ©
7131 ©
9322 173 29687
4822 130 60373
4822 130 60373
3198 010 42310
5322 130 60159
STP14NF12FP Power FET
BC856B
BC856B
BC847BW
BC846B
11-22
ELECTRICAL
––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––
TRANSISTORS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7203 © 3198 010 42310 BC847BW
7208 © 4822 130 60373 BC856B
7210 © 3198 010 44350 BC807-25W
7211 © 3198 010 42320 BC857BW
7218 ! 9322 173 29687 STP14NF12FP Power FET
7221 © 3198 010 44350
7222 © 9340 219 30115
7223 © 9340 219 30115
7227 ©! 9322 043 49685
7228 ©! 9322 043 49685
BC807-25W
BC817-25W
BC817-25W
MMBTA42
MMBTA42
7231 !
7238 ©
7239 ©
7240 ©
7243 ©
9322 173 29687
5322 130 60159
4822 130 60373
4822 130 60373
9340 219 30115
STP14NF12FP Power FET
BC846B
BC856B
BC856B
BC817-25W
7309 ©
7316 ©
7317 ©
7319 ©
7323 ©
3198 010 42310
3198 010 42320
3198 010 42310
3198 010 42310
9340 219 30115
BC847BW
BC857BW
BC847BW
BC847BW
BC817-25W
7324 ©
7402
7405 ©
7407 ©
7408 ©
9340 219 30115
4822 130 40855
3198 010 42320
9340 219 30115
9340 219 30115
BC817-25W
BC337-40
BC857BW
BC817-25W
BC817-25W
7409 ©
7410 ©
7411 ©
7505 ©
7506 ©
9340 219 30115
3198 010 42320
3198 010 44350
3198 010 42310
3198 010 42320
BC817-25W
BC857BW
BC807-25W
BC847BW
BC857BW
7509 ©
3198 010 42310
BC847BW
INTEGRATED CIRCUITS
–––––––––––––––––––––––––––––––––––––––––––––––––––––
7105 © 9350 694 90118 74LV14D
7118 © 9350 694 90118 74LV14D
7122 © 5322 209 11517 PC74HCU04T, HEX INVERTER IC
7209 © 9350 694 90118 74LV14D
7232 © 5322 209 11517 PC74HCU04T, HEX INVERTER IC
7235 ©
7310
7312 ©
7315
7320 ©
9350 694 90118
4822 209 14933
5322 209 11517
4822 209 81351
4822 209 83357
74LV14D
TL431IZ, PROGRAMMABLE VOLT. REF.
PC74HCU04T, HEX INVERTER IC
LM317MPTB
NJM4560M
7321
7400 ©
7406 ©
7508 ©
4822 209 81351
4822 209 31378
4822 209 17345
9322 150 74668
LM317MPTB
NJM4556M, 2-FOLD OP-AMP.
M62320FP, I2C SHIFT REGISTER
TDA7468D, SOURCE SEL. & SOUND

Service Manual MC-M570/21/21M/22/37

Transcription

Similar documents

Service Manual MCM7/22/37 - Page de test

Titel MPaxx - Vintages HiFi

Technical Service Manual

CD5000 - SManuals.ru

SIDE I/O

Service Manual

loewe concept l32

Viewing - Super TV Servis M+S

Hard Disc/DVD-Video Recorder HDRW720/0x, DVDR725H/0x