Aiwa CDC-R504MP, CDC-X504MP Service manual. www.s

Transcription

CDC-R504MP/X504MP
SERVICE MANUAL
US Model
Canadian Model
Ver 1.0 2004. 01
CDC-X504MP
AEP Model
UK Model
CDC-R504MP/X504MP
Photo: CDC-X504MP
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
CDX-R3300/R3300T
AUDIO POWER SPECIFICATIONS (US MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD Drive Mechanism Type
MG-611MA-186//Q
Optical Pick-up Name
KSS1000E
SPECIFICATIONS
Tuner section
Power amplifier section
FM
Tuning range
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W × 4 (at 4 ohms)
US, Canadian Model:
87.5 – 107.9 MHz
AEP, UK Model:
87.5 – 108 MHz
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
General
Outputs
Inputs
Tone controls
Power requirements
Dimensions
AM (US, Canadian Model)
Tuning range
530 – 1,710 kHz
Antenna terminal
Sensitivity
30 µV
Mounting dimensions
Mass
Supplied accessories
MW/LW (AEP, UK Model)
Tuning range
MW: 531 – 1,602 kHz
LW: 153 – 279 kHz
Antenna terminal
Sensitivity
MW: 30 µV
LW: 40 µV
Design and specifications are subject to change without
notice.
FM/AM COMPACT DISC PLAYER
US, Canadian model
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
Audio outputs terminal (rear/sub switchable)
Power antenna relay control terminal
Power amplifier control terminal
Telephone ATT control terminal (AEP, UK Model)
Antenna input terminal
Low: ±10 dB at 60 Hz (HIP-HOP)
Mid: ±10 dB at 1 kHz (HIP-HOP)
High: ±10 dB at 10 kHz (HIP-HOP)
12 V DC car battery (negative ground)
Approx. 178 × 50 × 176 mm
(7 1/8 × 2 × 7 in.) (w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)
Approx. 1.2 kg (2 lb. 10 oz.)
Parts for installation and connections (1 set)
Front panel case (1)
Card remote control RM-Z304
120 dB
10 – 20,000 Hz
Below measurable limit
FM/MW/LW COMPACT DISC PLAYER
AEP, UK model
9-877-518-01
Sony Corporation
2004A04-1
© 2004. 01
e Vehicle Company
Published by Sony Engineering Corporation
1
CDC-R504MP/X504MP
SERVICE NOTES
• US, Canadian model
CAUTION
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
• AEP, UK model
CAUTION
Use of controls or adjustments or performance of procedures other
than those specified herein may result in hazardous radiation
exposure.
This compact disc player is classified as a CLASS 1 LASER
product. The CLASS 1 LASER PRODUCT label is located on the
exterior.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
This label is located on the bottom of the chassis.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up
semi-fixed resistor
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDC-R504MP/X504MP
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable
CDs)
This unit can play the following discs:
Type of discs
Label on the disc
z
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Audio CD
MP3 files
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized∗.
• You can play MP3 files recorded on CD-ROMs, CD-Rs, and
CD-RWs.
• A CD-R/CD-RW to which a session can be added can be played.
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
∗ A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CN301) and the SERVO board (CN2)
with the extension cable (Part No. J-2502-076-1).
MAIN BOARD
CN301
J-2502-076-1
SERVO BOARD
CN2
3
CDC-R504MP/X504MP
TABLE OF CONTENTS
1. GENERAL
Location of Controls ................................................................ 5
Connections (US, Canadian Model) ........................................ 6
Connections (AEP, UK Model) ............................................... 7
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 9
2-2. CD Mechanism Block ......................................................... 9
2-3. Main Board ....................................................................... 10
2-4. Chassis (T) Sub Assy ........................................................ 10
2-5. Roller Arm Assy ................................................................ 11
2-6. Chassis (OP) Assy ............................................................. 11
2-7. Optical Pick-up ................................................................. 12
2-8. SL Motor Assy (M902) ..................................................... 12
2-9. LE Motor Assy (M903) ..................................................... 13
2-10. Servo Board ....................................................................... 13
3. DIAGRAMS
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
IC Pin Descriptions ........................................................... 14
Block Diagram –CD Section– ........................................... 19
Block Diagram –Main Section– ........................................ 20
Block Diagram –Display Section– .................................... 21
Circuit Boards Location .................................................... 21
Note for Printed Wiring Boards and
Schematic Diagrams .......................................................... 22
3-7. Waveforms ......................................................................... 22
3-8. Printed Wiring Boards –CD Mechanism Section– ............ 23
3-9. Schematic Diagram –CD Mechanism Section (1/2)– ....... 24
3-10. Schematic Diagram –CD Mechanism Section (2/2)– ....... 25
3-11. Schematic Diagram –Main Section (1/2)– ........................ 26
3-12. Schematic Diagram –Main Section (2/2)– ........................ 27
3-13. Printed Wiring Board –Main Section– .............................. 28
3-14. Printed Wiring Boards –Display Section– ........................ 29
3-15. Schematic Diagram –Display Section– ............................. 30
3-16. IC Block Diagrams ............................................................ 31
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
Main Section ..................................................................... 35
Front Panel Section ........................................................... 36
CD Mechanism Section (1) ............................................... 37
5. ELECTRICAL PARTS LIST ........................................ 41
4
CDC-R504MP/X504MP
SECTION 1
GENERAL
This section is extracted
from instruction manual.
LOCATION OF CONTROLS
5
CDC-R504MP/X504MP
CONNECTIONS (US, Canadian Model)
6
CDC-R504MP/X504MP
CONNECTIONS (AEP, UK Model)
7
CDC-R504MP/X504MP
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-1.
SUB PANEL ASSY
(Page 9)
2-2.
CD MECHANISM BLOCK
(Page 9)
2-3.
MAIN BOARD
(Page 10)
2-7.
8
2-4.
CHASSIS (T) SUB ASSY
(Page 10)
2-5.
ROLLER ARM ASSY
(Page 11)
2-6.
CHASSIS (OP) ASSY
(Page 11)
2-8.
SL MOTOR ASSY (M902)
(Page 12)
OPTICAL PICK-UP
(Page 12)
2-10. SERVO BOARD
(Page 13)
2-9.
LE MOTOR ASSY (M903)
(Page 13)
CDC-R504MP/X504MP
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
3 two claws
2 two claws
1 two screws
(+PTT 2.6 x 6)
4 sub panel assy
2-2. CD MECHANISM BLOCK
7 bracket (CD)
6 two screws
(+PTT 2.6 x 4)
5 CD mechanism block
2 screw
(+PTT 2.6 x 6)
3
1 screw
(+PTT 2.6 x 6)
4 CN301
9
CDC-R504MP/X504MP
2-3. MAIN BOARD
1 three ground point screws
(+PTT 2.6 x 6)
2 two screws
(+PTT 2.6 x 6)
3 MAIN board
insulating sheet
2-4. CHASSIS (T) SUB ASSY
4 claw
2 two screws
(+P 1.7 x 2.2)
1 two screws
(+P 1.7 x 2.2)
6 chassis (T) sub assy
5 SENSOR board
3 claw
10
CDC-R504MP/X504MP
2-5. ROLLER ARM ASSY
3 washer (0.8-2.5)
5 roller arm assy
4 worm wheel (RA)
2 spring (RAR)
1 spring (RAL)
2-6. CHASSIS (OP) ASSY
8
qa chassis (OP) assy
0 coil spring (damper)
lever (D)
4 washer
1 CN1
6
9 two coil springs (damper)
5 gear (LE1)
7
slider (R)
3 tension coil spring (KF)
2 Remove the six solderings.
11
CDC-R504MP/X504MP
2-7. OPTICAL PICK-UP
2 chucking arm sub assy
5 claw
1 tension coil spring (CHKG)
7 optical pick-up
6 main shaft
4 rack (SL)
3 screw
(+B 1.4 x 5)
2-8. SL MOTOR ASSY (M902)
1 screw
(+P 1.4 x 1.8)
2 SL motor assy (M902)
12
CDC-R504MP/X504MP
2-9. LE MOTOR ASSY (M903)
8 screw
(+M 1.7 x 2.5)
0 woam (LEB) assy
9 bearing (LEB)
qf two toothed lock screws
(+M 1.4 )
2 washer
qa screw
(+M 1.7 x 2.5)
3 gear (LE1)
lever (D)
4
bracket (LEM)
qs screw
(+M 1.7 x 2.5)
qd
qg LE motor assy
(M903)
5
6 screw
(+P 1.7 x 2.2)
slider (R)
7 leaf spring (LE)
1 Remove the soldering.
2-10. SERVO BOARD
1 Remove the eight solderings.
6 SERVO board
2 Remove the three solderings.
4 toothed lock screw
(M 1.7)
5 claw
3 CN1
13
CDC-R504MP/X504MP
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2))
Pin No.
Pin Name
I/O
Pin Description
1
MIRR
I/O
Mirrer signal input/output
14
2
3
DFCT
FOK
I/O
I/O
Defect signal input/output
Focus OK signal input/output
4
5
VSS
LOCK
—
I/O
Ground pin
Not used in this set. (Open)
6
7
MDP
SSTP
O
I
Spindle motor servo control signal output
Disc most inner detection signal input
8
9
IOVSS1
SFDR
—
O
Digital ground pin for I/O
Sled drive signal output
10
11
SRDR
TFDR
O
O
Sled drive signal output
Tracking drive signal output
12
13
TRDR
FFDR
O
O
Tracking drive signal output
Focus drive signal output
14
15
FRDR
IOVDD1
O
—
Focus drive signal output
Digital power supply pin for I/O
16
17
AVDD0
AVSS0
—
—
Analog power supply pin for I/O
Analog ground pin
18
19
NC
E
—
I
Not used. (Open)
E signal input
20
21
F
TEI
I
I
F signal input
Tracking error signal input from the DSSP block
22
23
24
TEO
FEI
FEO
O
I
O
Tracking error signal output to the RF amp block
Focus error signal input from the DSSP block
Focus error signal output form the RF amp block
25
VC
I/O
26
27
A
B
I
I
A signal input
B signal input
28
29
C
D
I
I
C signal input
D signal input
30
31
NC
AVDD4
—
—
Not used. (Open)
Analog power supply pin
32
RFDCO
I/O
RFDC signal output
RFDC signal input from the DSSP block by command select
33
34
PDSENS
AC SUM
I
O
Reference voltage input for PD
RFAC suming amp signal output
35
36
EQ IN
LD
I
O
Equalizer circuit signal input
APC amp signal output
37
38
PD
NC
I
—
APC amp signal input
Not used. (Open)
39
40
RFC
AVSS4
I
—
EQ cut off frequency adjustment input
Analog ground pin
41
42
RFACO
RFACI
O
I
RFAC signal output
RFAC signal input or EFM signal input
43
44
AVDD3
BIAS
—
I
Asymmetry circuit constant current input
45
46
ASYI
ASYO
I
O
Asymmetry comparate voltage input
EFM full swing signal output
47
48
VPCO
VCTL
O
I
Charge pomp output for wideband EFM PLL
VCO2 control voltage input for wideband EFM PLL
49
AVSS3
—
Analog ground pin
VC voltage output to the RF amp block
Center voltage input from the DSSP block by command select
CDC-R504MP/X504MP
Pin No.
50
Pin Name
CLTV
I/O
I
Pin Description
51
52
FILO
FILI
O
I
Filter signal output for master PLL
Filter signal input for master PLL
53
54
PCO
AVDD5
O
—
Charge pomp output for master PLL
55
56
DDVROUT
DDVRSEN
O
I
DC/DC converter output
DC/DC converter output voltage monitor signal input
57
58
AVSS5
DDCR
—
I
Analog ground pin
Reset signal input for DC/DC converter
59
60
NC
BCKI
—
I
Not used. (Open)
D/A interface bit clock signal input
61
62
PCMDI
LRCKI
I
I
D/A interface serial data signal input
D/A interface LR clock signal input
63
64
LRCK
VSS
O
—
D/A interface LR clock signal output
Digital ground pin for internal
65
66
PCMD
BCK
O
O
D/A interface serial data signal output
D/A interface bit clock signal output
67
68
VDD
EMPH
—
O
Digital power supply pin for internal
69
70
EMPHI
IOVDD2
I
—
Not used in this set. (Fixed at “L”.)
71
72, 73
DOUT
TEST
O
I
Digital out signal output
Test pin Normally “L”.
74
75
76
IOVSS2
NC
XVSS
—
—
—
Ground pin for master clock
77
78
XTAO
XTAI
O
I
Crystal oscillation circuit output (16.9344 MHz)
Crystal oscillation circuit input (16.9344 MHz)
79
80
XVDD
AVDD1
—
—
Power supply pin for master clock
81
82
AOUT1
VREFL
O
O
L channel analog signal output
L channel reference voltage output
83
84
AVSS1
AVSS2
—
—
Analog ground pin
Analog ground pin
85
86
VREFR
AOUT2
O
O
R channel reference voltage output
R channel analog signal output
87
88
AVDD2
NC
—
—
Not used. (Open)
89
90
IOVDD0
RMUT
—
O
R channel “O” detection flug output
91
92
LMUT
NC
O
—
L channel “O” detection flug output
Not used. (Open)
93
94
XTSL
IOVSS0
I
—
X’tal select signal input 16.9344 MHz: “L”, 33.8688 MHz: “H”
95
96
XTACN
SQSO
I
O
Oscillation circuit control input “H”: Oscillation start, “L”: Oscillation stop
Sub 80 bit and PCM peak, level data signal output CD text data signal output
97
98
SQCK
SBSO
I
O
Clock signal input for SQSO read out
Sub P-W serial data signal output Not used in this set. (Open)
99
100
EXCK
XRST
I
I
Clock signal input for SBSO read out Not used in this set. (Open)
System reset signal input “L”: reset
101
102
SYSM
DATA
I
I
Mute signal input “H”: mute
Serial data signal input
103
VSS
—
Digital ground pin for internal
VCO1 control voltage input
Not used in this set. (Fixed at “L”.)
15
CDC-R504MP/X504MP
Pin No.
104
Pin Name
XLAT
I/O
I
Latch signal input
105
106
CLOK
VDD
I
—
Serial data transfer clock signal input
107
108
SENS
SCLK
O
I
SENS signal output
Clock signal input for SENS serial data read out
109
110
ATSK
WFCK
I/O
O
111
112
XUGF
XPCK
O
O
XUGF signal output
XPCK signal output
113
114
GFS
C2PO
O
O
GFS signal output
C2PO signal output
115
116
SCOR
VDD
O
—
Sub cord sync signal output
117
118
C4M
WDCK
O
O
4.2336 MHz signal output Not used in this set. (Open)
Word clock signal output Not used in this set. (Open)
119
120
COUT
NC
I/O
—
16
Pin Description
Input/output for anti-shock
WFCK signal output Not used in this set. (Open)
Track count signal input/output
Not used. (Open)
CDC-R504MP/X504MP
• IC501 MN101E01KSH (SYSTEM CONTROL) (MAIN BOARD (1/2))
Pin No.
Pin Name
I/O
Pin Description
1
DAVDD
—
Power supply pin for D/A output converter (+3.3 V)
2
3
BBE-MP
DAVSS
O
—
Ground pin for D/A output converter
4 to 6
7
NCO
UNISO
O
O
SONY-BUS data signal output
8
9
UNISI
UNICKO
I
O
SONY-BUS data signal input
SONY-BUS clock signal output
10
11
VDD1
MMOD
—
I
Power supply pin for internal core (+3.3 V)
Flash microcomputer write detection signal input
12
13
OSCOUT
OSCIN
O
I
High speed operation clock signal output (27 MHz)
High speed operation clock signal input (27 MHz)
14
15
VSS1
XIN
—
I
Ground pin for internal core
Low speed operation clock signal input (32.768 kHz)
16
17
XOUT
VDD2
O
—
Low speed operation clock signal output (32.768 kHz)
Power supply pin for internal core (+3.3 V)
18
19
MOD1
RESET
—
I
Pull up: “H”
Reset signal input
20
21
NCO
ACC IN
O
I
Accessory power supply detection signal input
22
23
TEST IN
TEL ATT
I
I
Test mode detection signal input
Telephone attenuate detection signal input
24
25
ATT
XKEYON
O
O
Audio mute control signal output
Key power supply control signal output Not used in this set. (Open)
26
27
28
NCO
KEYACK
TU ATTIN
O
I
I
Key acknowledge detection signal input
Tuner mute ZERO cross detection signal input
29, 30
31
NCO
BUIN
O
I
Back up power supply detection signal input
32 to 35
36
NCO
BUSON
O
O
BUS on signal output
37
38
SYSRST
EJECT OK
O
O
System reset signal output
CD servo IC eject OK signal output
39 to 41
42
NCO
Z MUTE
O
I
Mechadeck mute zero cross detection signal input L/R
43 to 46
47
NCO
CD ON
O
I
CD mechanism power supply control signal input (“H”: Power on)
48
49, 50
CDM ON
NCO
I
O
CD mechanism deck power supply control signal input (“H”: Power on)
51
52
AREASEL1
AREASEL2
I
I
Destination function setting input 1
53
AREASEL3
I
54
LCD CTL
O
“H” output: LCD unit and key confusion, power off
55, 56
NCO
O
“L” output: LCD unit and key confusion, power on
57
58
DSSA
PANEL SW
O
I
DSSA on/off change signal output (Cut off rear)
Front panel attachment detection signal input “L”: with panel, “H”: without panel
59
60
DIAG
VOLATT
I
O
Condition signal input from the power IC
Electronic volume attenuate control signal output
61, 62
63
NCO
VSS2
O
—
Ground pin for I/O port
64
65
TU ATT
NCO
O
O
Tuner mute control signal output
Not used in this set.
17
CDC-R504MP/X504MP
Pin No.
66
Pin Name
NS MASK
I/O
O
Noise mask signal output
67
68
EEP CKO
EEP SIO
O
I/O
Serial clock signal output for EEPROM communication
Serial data signal input/output for EEPROM communication
69
70
NCO
AMPSTB
O
O
Power regulator IC standby signal output
71 to 73
74
NCO
NCO
O
O
75
76
NCO
LCDSO
O
O
Serial data signal output to the LCD driver
77
78
LCDCE
LCDCKO
O
O
Chip enable signal output to the LCD driver
Serial clock signal output to the LCD driver
79
80
I2C SIO
NCO
I/O
O
81
82
I2C CKO
DAVN
O
I
I2C BUS serial clock signal output
RDS data block synchronization detection signal input
83
84
SIRCS
NCO
I
O
Remote control signal input
85
86 to 88
BEEP
NCO
O
O
Beep signal output to the power amp
89
90
VDD3
NCO
—
O
Power supply pin for I/O port (+3.3 V)
91
92
VSS3
QUALITY
—
I
Ground pin for I/O port
Noise detection signal input
93
94
95
VSM
KEYIN1
KEYIN0
I
I
I
S meter voltage detection signal input
Key signal input 1
Key signal input 0
96
97
NCO
KEYIN2
O
I
Key signal input (EJECT, OFF, SOURCE switch)
98
99
RE
L METER
I
I
Rotary encoder signal input
Level meter voltage detection signal input
100
VREF+
—
Power supply pin for A/D input converter
18
Pin Description
I2C BUS serial data signal input/output
CDC-R504MP/X504MP
3-2. BLOCK DIAGRAM — CD SECTION —
• R-ch is omitted due to same as L-ch.
• Siganal Path
: CD PLAY
DETECTOR
PD1
PD2
PD2
26 A
PD1
42 RFACI
RFACO 41
ASYO 46
45 ASYI
AOUT2 86
27 B
CD-L
AOUT1 81
A
MAIN
SECTION
(Page 20)
R-CH
28 C
I-V AMP
29 D
E
E
F
F
RF AMP,DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC3
19 E
FEO 24
23 FEI
20 F
TEO 22
21 TEI
PD
LD
AUTOMATIC
POWER
CONTROL
Q1
36 LD
PD 37
PD
23 CD RMUT
19
16
18
15
14
13
12
11
10
8
7
52
3
96
97
100
102
104
105
107
108
113
114
115
CD FOK
CD SQSO
CD SQCK
CD XRST
CD DATA
CD XLAT
CD CLOK
CD SENS
CD SCLK
CD GFS
CD C2PO
CD SCORT
UNISI
RXD
UNISO
TXD
UNICLK
BUS ON
BU IN
RSTX
A ATT
UNI SI
56
25
57
26
58
50
51
75
60
UNI SO
UNI SCK
BUS ON
BU IN
SYS RST
ATT
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING
MOTOR DRIVE
IC1
EJECT OK 61
FCS–
11 VO2–
VIN2+ 22
13 FFDR
10 VO2+
VIN2– 21
14 FRDR
13 VO1–
VIN1+B 19
11 TFDR
12 VO1+
VIN1–B 18
12 TRDR
MECHA+6V
SERVO+3.3V
+1.5V REG
IC7
X2
18.43MHz
XTAO 77
80 X0
+1.5V
(FOCUS)
+1.5V
CONTROL
Q2,3
5 VOUT
VDD 1
CE 3
(TRACKING)
TRK+
TRK–
SW1
(DOWN)
46 MEC_DSW
+3.3V
M902
(SLED)
M
M901
(SPINDLE)
M
M903
(LOADING)
M
6 VO4+
VIN4+ 31
9 SFDR
7 VO4–
VIN4– 32
10 SRDR
8 VO3+
VIN3+ 25
6 MDP
BCK
BCKI
PCMDI
LRCK
LRCKI
PCMD
66
60
61
63
62
65
9 VO3–
5 VOL+
4 VOL–
SW2
(SELF)
53 MEC_SELFSW
45 MEC_INSW
SW4
(LIMIT)
42 MEC_LIMIT
MUTE 34
41 DRON
FWD 1
43 MEC LOAD
REV 2
44 MEC EJECT
19
+3.3V
CONTROL
Q5,6
DECON 65
SW3
(DISC IN)
19
(Page 20)
48 CDM ON
47 CD ON
42 Z MUTE
MECON 63
CDON 64
ZMUT 66
81 X1
X1
16.934MHz
MAIN
SECTION
38 EJECT OK
CDON CHK 68
XTAI 78
FCS+
B
SYSTEM CONTROL
IC501 (1/3)
CD
SYSTEM CONTROL
IC4
MECON CHK 67
OPTICAL
PICK-UP BLOCK
(KSS1000E)
2-AXIS DEVICE
22 CD LMUT
RMUTE 90
FOK
SQSO
SQCK
XRST
DATA
XLAT
CLOK
SENS
SCLK
GFS
C2POT
SCOR
LASER DIODE
LD
LMUTE 89
AUDIO INTERFACE
IC8
DEC XMUTE
DEC SSTBY
DEC XRST
DEC STBY
DEC INT
DEC SCL
DEC SDA
EMPH
37
27
28
29
30
31
32
69
22
41
2
3
36
7
6
28
CLCK
SRMSTB
RESET
STANDBY
BUCK
I2C SCL
I2C SDA
BUSO
15
18
11
16
19
14
BCK1A
BCK1B
SD0O
LRCK1A
LRCK1B
SD1O
U COM+3.3V
CDC-R504MP/X504MP
3-3. BLOCK DIAGRAM — MAIN SECTION —
SOUND CONTROL,
ELECTRONIC VOLUME
IC401
J601
(AUX IN)
R-CH
R-CH
CD
SECTION
TU1
(TUNER UNIT)
J1
(ANTENNA)
1 ANT
A
CD-L
R-CH
(Page 19)
L 4
R 3
5 AUX-LCH
3 AUX-RCH
9 CD-LCH
8 CD-RCH
OUT SUB L 17
OUT SUB R 18
L
R-CH
7 TU-LCH
6 TU-RCH
OUT-FL 23
OUT-RL 22
OUT-FR 25
OUT-RR 24
VCC 10
TU VDD 11
E2P VDD 15
TU-SCL 13
TU-SDA 14
AUDIO+8.3V
LEVEL METER
VOLTAGE DETECT
D401,402,Q401
TU+5V
BACK UP+3.3V
15 OUT-SEL-R
16 OUT-SEL-L
11 IN-RL
R-CH (FRONT)
R-CH (REAR)
MUTE 29
SCL 30
SDA 31
SCL
SDA
REAR L/R
CUT OFF
SWITCH
Q403
DSSA ON/OFF
SWITCH
Q402
MUTE
Q431
MUTE DRIVE
Q491,492
10
D492
SYSTEM CONTROL
IC501 (2/3)
RDS DEMODULATOR
IC51
R-CH
BATT
I2C CKO 81
99 L METER I2C SIO 79
VOL ATT 60
16 MPX
9 XTI
SCL 11
SDA 12
ATT
BEEP
AMPSTB
DIAG
SCL
SDA
SDA
SCL
SCL
SDA
5
AMP-REM
6
ANT-REM
82 DAVM
FU601
2 SDA
4 SCL
16 BEEP
22 STB
25 DIAG
BATT
BACK UP
+3.3V
AUDIO+8.3V
B.UP+B
SERVO+3.3V
MECHA+6V
PANEL+B
30
37
31
33
34
AUDIO+8.3V
BACK UP+3.3V
SERVO+3.3V
MECHA+6V
PANEL+10V
ACC CHECK
Q631
7
TEL ATT
Q651
13
15
28 TU ATTIN TEST IN 22
R504MP
QUALITY 5
92 QUALITY
NS MASK
SWITCH
Q3
TU+5V
TU+5V REG
Q1
AUDIO+8.3V
66 NS MASK
BUIN 31
S-METER 6
TU MUTE 7
93 VSM
64 TU ATT
E2P SCL 16
E2P SDA 17
67 EEP CKO
68 EEP SIO
BATTERY
CHECK
Q582
D580
LOW VOLTAGE
DETECT
Q581
BATT
OVER VOLTAGE
DETECT
Q580
D581
• R-CH is omitted due to same as L-CH.
• Signal Path
: CD PLAY
: FM
7
8
9
36
37
UNI SO
UNI SI
UNI SCK
CD
SECTION
B
BUS ON
SYS RST
UNI SO
UNI SI
UNI SCK
BUS ON
SYS RST
: AM/MW/LW
: AUX
(Page 19)
BU IN
ATT
DISPLAY
SECTION
C
BATT
35 VP
R504MP/X504MP:
AEP,UK MODEL
TEL ATT 23
MULTI
8
CONDITION
16
DSSA 57
ACC IN 21
B+ SWITCH
Q51,52
BATT
D503
24
85
70
59
10 XTO
INTN 15
VDDA VDDD
1
7
RL+
RL–
4
FR+
12
FR–
3
RR+
11
RR–
AMP-REM 29
ANT-REM 27
R504MP
X51
8.664MHz
2
OUT-RL+ 9
OUT-RL– 7
MUTE
Q451
SCL
SDA
RDS 9
CN601
1
FL+
9
FL–
OUT-FL+ 5
OUT-FL– 3
12 IN-FL
R
R-CH
POWER AMP
MULTIPLE VOLTAGE
REGULATOR
IC750
MUTE
Q481
D301
RESET
(Page 21)
20
20
J331
AUDIO OUT
REAR
ACC
ATT
TEST
CDC-R504MP/X504MP
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
SYSTEM CONTROL
IC501 (3/3)
ROTARY
ENCODER
S911 (1/2)
3-5. CIRCUIT BOARDS LOCATION
LCD DRIVER
IC901
98 RE
KEY MATRIX
S901-903
97 KEYIN2
LCD SO 76
LCD CKO 78
LCD CE 77
64 DI
63 CLK
CL
62 CE
SERVO board
SEG3 3
|
|
SEG50 50
COM1 54
|
|
COM4 51
SENSOR board
LCD901
LIQUID
CRYSTAL
DISPLAY
PANEL
27 KEYACK
DIMMER
DIMMER 1
KEY MATRIX
S904-910
S911 (2/2)
94 KEYIN1
KEY MATRIX
S912-920
95 KEYIN0
DIMMER
CONTROL
Q901
(
LED921,922
LCD
BACK LIGHT
)
tuner unit
(TU1)
PANEL+10V
KEY board
MAIN board
LCD CTL 54
RESET
IC602
BACK UP+3.3V
2 IN
LED901-920
PANEL+3.3V
SWITCH
Q503
19 RESET
OUT 1
S702
RESET
MAIN
SECTION
C
RESET
SIRCS 83
(Page 20)
1
VCC
2 OUT
AUX board
BUCK UP+3.3V
IR
REMOTE CONTROL
SIGNAL RECEIVER
IC971
X502
32.768kHz
15 XIN
16 XOUT
OSCIN 13
OSCOUT 12
X501
27MHz
21
21
CDC-R504MP/X504MP
3-6. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
3-7. WAVEFORMS
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
— Servo Board —
1
For schematic diagrams.
For printed wiring boards.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
: internal component.
•
• C : panel designation.
Note:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
: Through hole.
•
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
•
•
•
•
•
•
•
•
•
•
•
Note:
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
A : B+ Line.
B : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
CD mechanism section
no mark : CD PLAY
Main (1/2), (2/2) and Display sections
no mark : FM
(
) : AM
<
> : CD PLAY
∗
: Impossible to measure
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
J : CD PLAY
F : FM
f : AM/MW/LW
a : AUX
Abbreviation
CND : Canadian model.
— Main Board —
(MODE: CD PLAY)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
1
27MHz
Approx. 100mVp-p
wa
IC3
IC501
(TEI)
2
qs
(OSCOUT)
2
1.8Vp-p
0V
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
32.768kHz
Approx. 100mVp-p
wd
IC3
IC501
(FEI)
3
qg
(XIN)
3
Approx.
150mVp-p
C
Q
2.2Vp-p
0V
0.9Vp-p
These are omitted
B E
IC3
wh
(A), wk (C)
4
Approx.
150mVp-p
BE C
These are omitted
IC3
wj
(B), wl (D)
5
ECB
Approx.
0.8Vp-p
These are omitted
• Abbreviation
CND : Canadian model.
ra
IC3
(RFACO)
6
2Vp-p
16.9344MHz
IC3
uj
(XTAO)
7
1Vp-p
18.43MHz
IC4
22
22
ia
(X1)
IC51
q;
(XTO)
CDC-R504MP/X504MP
3-8. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Circuit Boards Location.
2
1
R107
7
8
9
10
C47
C44
C43
C49
R68
C59
R67
R71
R98
R1
C4
C107
R80
R129
R62
R59
R50
R52
R143
C53
R48
C48
B7
R64
R128
R110
C58
FM
R142
C86
R126
R145
C81
C75
C55
R78
R79
R122
C57
R99
R144
R72
R70
C54
C65
C115
C64
C77
R61
R111
R108
C10
R56
C50
R49
C110
R97
R141
SW3
C5
R119
R73
FB2
R115
C32
E
R74
1
C66
CN
R81
IC4
R37
C109
R46
R54
C79
C37
R44
R55
X1
BP1
R127
R60
IC8
IC3
R12 R7
C45
R43
R77
C
R13
C27
C6
C40
R42
R45
C42
R109
R8
R20
Q1
C38
C46
C39
R41
R149
C35
R38
C41
C91
C34
Q3
R24
R40
C85
R140
14
R28
C30
R25
C33
IC7
R116
SW2
R87
R57
C67
FB1
R147
R123
R146
R26
R17
R4
C8
C19
R27
C26
C7
R21
R5
C63
R148
R16
R18
C51
CN2
R133
R114
R86
FB5
R124
R39
C60
R136
R92
R91
R47
C56
C36
R117
B8
X2
C2
R69
FM
R85
R65
C1
F
13
R2
R9
R19
C25
R23
R22
C28
D
12
R3
BP2
R53
C29
R29
C92
11
BP3
R76
C22
Q2
C23
C24
R101
R139
R106
C74
6
Q5
C83
B
5
R6
Q6
4
C52
A
3
: Uses unleaded solder.
C18
(Page 28)
G
C21
IC1
C3
R15
R14
C13
C14
R11
C11
C16
R10
SW1
H
• Semiconductor
Location
23
23
Ref. No.
IC1
IC3
IC4
IC7
IC8
Location
G-2
C-10
E-2
B-2
C-2
Q1
Q2
Q3
Q5
Q6
B-4
B-2
B-2
A-2
A-2
CDC-R504MP/X504MP
3-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 22 for Waveforms.
R67
R60
R56
TP141
TP137
TP127
TP116
R59
R52
C41
R40
TP98
TP97
R50
TP96
R149
R48
TP343
TP344
TP62
TP63
TP65
C33
TP94
C45
R71
C54
TP59
TP60
TP57
R64
TP61
C52
C58 TP180
C53
C59
C60
R97
R29
TP181
R98
CN2
C29
TP129
IC3
R70
C28
C81
TP72
TP123
R77
TP128
TP139
TP53
X1
TP56
TP140
TP55
R13
C22
R6
BP2
R22
C24
C25
CN1
TP21
TP167
FB2
FB5
TP71
BP3
R25
R23
TP175
R114
TP22
TP23
R79
TP24
TP25
R68
R1
R72
C6
TP32
R45
R43
R54
C48
C47
R53
C44
C38
R46
C43
C30
C10
C46
C64
(Page 25)
24
24
R61
C49
R55
R49
R41
C42
R12
R44
R7
C39
C40
TP45
C37
R38
TP44
C34
C35
Q1
TP99
C50
C5
TP135
TP42
R124
TP51
TP37
TP41
TP132
TP36
TP39
TP38
TP43
TP33
TP34
TP35
TP133
R133
TP136
TP46
R42
C4
TP28
TP29
TP30
TP49
TP47
C57
R78
R76
TP50
C27
TP26
TP27
TP54
TP48
C55
R24
C23
R65
C65
C107
TP40
(Page 26)
CDC-R504MP/X504MP
• Refer to page 22 for Waveform.
3-10. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 31 for IC Block Diagrams.
(Page 24)
FB1
R69
R146
R47
R148
R39
R73
C56
R147
R57
C36
R136
C67
R91
R81
R92
TP7
SW4
C63
TP8
R15
R117
R14
X2
TP9
TP11
SW3
R85
R86
C1
IC B/D
C2
C32
IC1
R37
R87
TP12
SW2
C21
C3
TP19
SW1
TP20
IC4
R140
C11
R18
C19
R20
C66
R19
TP17
R17
C18
M903
R145
R123
TP18
R141
TP58
M901
C26
TP14
TP15
R26 R27
R16
M902
C7
R28
R4
R2
TP52
R11
R74
R80
R62
R129
R5
R127
R128
R122
R3
R9
R126
C16
C8
R115
TP31
C14
R119
C51
R8
C13
R10
C115
C86
R111
R110
C92
C77
C75
C109
R99
R144
R108
C79 TP226
BP1
IC8
C110
R109
IC B/D
TP230
TP231
IC7
Q5
Q3
C83
C85 R106
R101
R107
R139
Q6
TP249
TP16
R142
R143
R21
TP13
C74
R116
C91
25
Q2
25
CDC-R504MP/X504MP
• Refer to page 22 for Waveforms.
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 32 for IC Block Diagrams.
IC B/D
TU1
IC B/D
C416
R428
C407
C402
C430
R59
C51
R51
Q51
R52
J1
C55
C56
C54
C57
C406
C405
C419
C4
R6
R4
C408
R418 C428
R9
C415
R429
Q402
R410
R415
Q401
R411
C425 R413
Q503
C412
C411
C410
C426 R414 C409
R61
R7
R407
R409
R401
R419
C429
R5
R10
R8
D402
C2
IC51
R15
R16
C1
C9
C3
C8
C7
D401
R53
Q3
R406
R408
C420
Q52
Q403
C427
R405
R422
R421
C58
R54
C53
C401
R12
R11
C404
C403
C52
IC401
R416
R417
R402
L1
R1
R56
R58
C62
D1
R57
R55
C6
X51
C60
C59
Q1
C5
R540
R559
JC26
R539
R519
R530
R528
R573
R532
R557
(Page 27)
R560
R563
R636
R531
R549
R538
R520
R564
D503
R534
R537
L304
L305
L306
C509
C515
R506
C301
CN301
C305
C508
R556
R303
JW143
C507
R552
R551
X502
R547
IC501
X501
R508
R509
JW142
D586
C302
C303
C310
C504
R579
R591
C307
L302
R593
L303
L307
D587
R544
R592
L310
(Page 24)
C503
C501
R567
R558
R514
R513
C309
L308
JW144
L309
JW145
26
26
C513
C517
R565
R543
C511
R504
C308
R503
R502 R596
C514
C502
R501
R518
R541
C512
R522
JC19
C516
D301
R511
R521
C304
C510
R512
R510
R595
R505
R566
R535
CDC-R504MP/X504MP
3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 34 for IC Block Diagram.
C441 R441
C765
Q441
R442
C766
C764
D751
C751
D753
R462
C461
R461
C431
R431
Q461
J331
C333
C334
C750
D755
Q431
D757
R432
R452
Q451
D752
C451 R451
CN601
D754
C481 R481
Q481
R482
IC750
R443 C442
D756
D758
R472
C471
D761
Q471
R471
R463
C462
D759
D760
R609
R493
D492
C625
FU601
C626
C624
C452
C631
C629
C627
R453
D762
C630
C628
C432
C617
C618
Q492
R433
D491
C492
R492
IC B/D
C753
D609
Q491
L601
R491
C602
C601
D601
C491
C701
C758
(Page
26)
R752
R756
C759
C760
C754
C755
C756
C761
JC2
L502
IC602
C731
C732
R735
C703
S702
C623
R731
R732
L373
L374
R734
R733
C622
C621
L501
D703
L372
L731
D731
CN701
D702
R701
JW53
R631
R633
R653
Q631
R652
Q651
R634
C632
R651
R632
R654
D651
(Page 30)
Q581
R584
C704
R585
D581
D712
D711
D580
R582
Q582
Q580
R583
27
27
CDC-R504MP/X504MP
3-13. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 21 for Circuit Boards Location.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
J331
J1
A
CN601
Q431
JW147
C766
C630
R482
FU601
C627
B
IC750
X504MP:US,CND MODEL
C628
C626
C624
C751
R442
C629
JW9
C631
C333
C765
C764
Q441
R432
JW141
JW5
JW7
D762
D761
D753
JW28
JW29
R652
JW118
JC2
L302
R540
JW114
JW115
JW40
C301
L308
C309
R633
JW50
JW47
JW46
JW53
JW52
R593
R563
R636
R564
JW51
D587
C509
JW62
JW63
JW58
JW64
R585
CN701
D731
S702
J
(Page 29)
28
28
JW140
JW44
JW65
JW41
R591
C632
R535
R584
C517
R579
JW37
JC13
L501
R543
R508
Q581
Q631
JW36
R634
R539
JW60
IC602
C503
JW82
Q580
JC26
D586
JW142
JW143
JW45
JW49
C507
C508
X502
C621
C703
JC11
R609
C303
C308
C304
JW110
D301
FMB4
C513
C512
JC17
JC18
R596
X501
JW66
R503
R565
• Semiconductor Location
R632
C502
R566
R505
R595
C504
JW135
D711
D712
R504
C701
D703
L374
R502
JC20
R701
L372
JC22
R732
R731
L731
C514
D702
L373
JW99
R303
C516
JW103
JW139
JW57
JW117
R631
R509
JC14
C501
R501
R556
R547
C510
R506
JW129
C511
JW125
R518
JW74
JW133
JW68
C704
JW71
C731
JW70
C732
JW76
R733
JW75
R734
JW126
R735
JW105
JW98
JW55
R552
JW77
I
JW106
C623
JW119
R512
R541
R511
R583
D581
R519
R559
C515
JC19
R567
JW145
Q582
R560
R510
R558
JW78
C601
JW134
JW128
JW42
C622
JW112
JW25
JW23
R513
R514
R756
JW104
JW127
C420
JW69
JW121
JW122
R592
C58
H
R573
IC501
R61
D580
D609
JW138
C756
C59
JW123
JW124
R55
JW80
IC51
JW84
C57
R53
R52
JW73
R9
X51
C60
C53
JW4
JW8
D756
D758
C750
C761
R752
C755
R534
C56
R51
R54
R530
JW56
C54
C51
R8
R582
JW144
L309
R56
C55
C307
JW130
B3
R5
C405
JW107
L306
JW109
R549
JW87
JW86
L307
R520
JW88
JW85
R57
R58
C52
L303
R551
R528
R59
JW43
C305
L310
R521
R544
Q52
JW116
L305
D503
JW33
C302
FM
G
Q51
C62
L304
C406
JW97
R522
JW89
JW35
JW113
C310
JW96
JW67
JW81
JW48
R6
Q403
JC7
JW90
JW34
R531
JW92
JW27
D401
JW39
Q503
R532
C9
JW79
JW54
JC25
JW26
JW101
JW38
JW83
JC6
R491
JW95
C419
R557
JW72
R16
JW91
D402
R15
R492
JW93
C754
R417
JW30
CN301
R493
JW61
L1
R415
JW32
Q651
D491
R402
R419
Q1
JW94
R416
C5
R411
R410
R422
C429
R1
C410
R538
Q401
D1
R4
C758
C411
R421
R537
R413
C425
C492
D492
C415
R409
JW31
C760
C491
R429
Q492
R414
C428
C4
C416
R408
C426
C2
R407
R504MP/X504MP:AEP,UK MODEL
D601
R654
JW111
Q491
Q402
C409
D760
C602
JW59
JW24
C427
JW20
JW108
R401
R428
JW131
C408
R406
R418
C3
R11
JW132
IC401
R12
L601
D759
C759
L502
R405
C1
JW100
D752
Q461
R471
C461
C471
C412
C404
JW102
C401
C8
R651
D651
D755
D757
C430
R7
D751
JW22
C403
C6
D754
R461
C451
C481
R481
C334
R472
C407
R462
C441
Q3
E
R653
JW18
R441
C7
R10
R452
C617
JW137
JW6
JW17
C431
D
C618
JW16
R451
C402
JW2
JW3
JW10
JW11
C452
R453
JW12
JW15
JW13
C462
JW14
JC24
R463
Q451
TU1
F
C753
C442
R443
R431
Q471
C432
JC10
Q481
JW146
JW120
C
C625
JW1
R433
JW136
(Page 23)
Ref. No.
D1
D301
D401
D402
D491
D492
D503
D580
D581
D586
D587
D601
D609
D651
D702
D703
D711
D712
D731
D751
D752
D753
D754
D755
D756
D757
D758
D759
D760
D761
Location
E-2
H-7
F-4
F-4
E-6
E-5
F-6
F-10
F-10
G-8
H-8
D-9
G-10
C-8
I-4
I-4
I-3
I-3
J-2
D-6
C-5
D-7
C-5
D-7
C-6
D-6
C-6
C-8
D-8
D-8
Ref. No.
D762
Location
D-9
IC51
IC401
IC501
IC602
IC750
G-2
E-3
H-6
H-8
B-6
Q1
Q3
Q51
Q52
Q401
Q402
Q403
Q431
Q441
Q451
Q461
Q471
Q481
Q491
Q492
Q503
Q580
Q581
Q582
Q631
Q651
F-2
D-2
G-2
G-3
E-3
E-4
E-4
A-3
B-3
C-4
C-4
B-3
C-3
E-5
E-5
E-6
G-10
G-10
G-10
G-9
D-8
CDC-R504MP/X504MP
3-14. PRINTED WIRING BOARDS — DISPLAY SECTION — • Refer to page 21 for Circuit Boards Location.
2
1
A
3
4
5
6
7
8
9
10
11
12
13
IC971
LED920
LED903
14
S901
S903
LED902
S902
D9
LE
14
15
S9
LED901
B
D9
17
LE
S910
S9
LED919
13
LED904
14
S9
15
LED922
D9
16
LED921
LE
D9
12
S916
S9
LED908
LED906
LCD901
S908
C
LE
S909
S917
S907
LED907
LED905
LED910
LED911
LED913
LED909
LED912
S906
S919
S920
S904
S905
LED918
S918
D
(Page 28)
E
D904
R912
R911
R940
D901
R902
R972
C904
R909
R901
R939
H
• Semiconductor Location
Ref. No.
D901
D902
D904
D991
D992
Location
G-10
F-9
F-11
F-8
E-7
IC901
IC971
F-7
A-13
LED901
LED902
B-4
B-2
Ref. No.
LED903
LED904
LED905
LED906
LED907
LED908
LED909
LED910
LED911
LED912
LED913
Location
A-2
B-1
D-5
C-3
D-2
C-2
D-7
D-7
D-5
D-9
D-9
Ref. No.
LED914
LED915
LED916
LED917
LED918
LED919
LED920
LED921
LED922
Location
C-12
B-12
C-11
B-11
D-11
B-13
A-12
C-4
C-10
Q901
F-6
29
29
R938
R937
R910
R971
R981
R982
JC905
R914
R913
R915
C971
R932
R987
R988
R922
C905
R983
C903
R994
IC901
S911
G
R916
D991
D902
C993
R903
R991
C991
Q901
R931
CN901
R917
C992
R995
R953
R952
R951
R950
R936
R933
R921
R920
R919
C901
C902
R918
R908
R934
F
JC903
C906
C995
C994
R992
C996
R996
R904
R907
R905
R984
R986
R985
R993
D992
R935
R906
J601
CDC-R504MP/X504MP
3-15. SCHEMATIC DIAGRAM — DISPLAY SECTION —
R931
R933
R935
C906
R937
R939
R921
R987
CN901
R932
R934
R936
LED905
C904
R938
LED909
LED914
R940
R922
R972
R988
LED920
C905
LED921
LED901
IC971
LED908
LED911
LED915
LED919
LED922
R971
LED903
C971
R981
(Page
27)
R982
R983
LED906
LED910
LED913
LED917
Q901
LED902
R953
R991
LED904
LED907
LED912
LED916
C992
LED918
C903
R951
C991
R952
IC901
R994
R995
C993
R996
D992
D901
D902
D904
R950
R993
R992
C994
R984
C995
D991
R986
C996
R985
JC905
J601
JC903
R920
R901
R918
R902
R919
C901
S901
S902
C902
S903
S911
S904
S905
S906
S907
S908
S909
S910
LCD901
R903
S912
R904
R905
R910
R911
R912
S913
S914
S915
R906
R907
R913
R914
R915
R916
S917
S918
S919
S916
R908
R909
R917
S920
30
30
CDC-R504MP/X504MP
3-16. IC BLOCK DIAGRAMS
IC1 LA6560-TE-L-E (SERVO Board)
FWD 1
36 S-GND
THERMAL SHUTDOWN
INPUT
REV 2
35 VCONT
VCC2 3
OUTPUT
CONTROL
VLO- 4
BTL-AMP
OUTPUT
ON/OFF
MUTE
34 MUTE
33 VIN4
VLO+ 5
32 VIN4-
LEVEL
SHIFT
VO4+ 6
31 VIN4+
VO4- 7
30 VREF-IN
LEVEL
SHIFT
VO3+ 8
VO3- 9
VIN1/VREF-SW
29 VIN1-SW
28 VREF-OUT
GND
GND
27 REG-OUT
LEVEL
SHIFT
VO2+ 10
26 REG-IN
VO2- 11
25 VIN3+
LEVEL
SHIFT
VO1+ 12
24 VIN3-
VO1- 13
23 VIN3
VCC1 14
22 VIN2+
VIN1 15
21 VIN2AMP-A
20 VIN2
VIN1-A 16
L
VIN1+A 17
H
VIN1-B 18
AMP-B
19 VIN1+B
31
CDC-R504MP/X504MP
IC7 R1114N151D-TR-FA (SERVO Board)
VDD 1
5 VOUT
GND 2
VREF
CURRENT
LIMIT
CE 3
4 NC
IC51 TDA7333-013TR (MAIN Board)
3
INTERPOLATOR
BAND PASS
FILTER
REF2 3
REF1 4
VSS 5
TM 6
VDDD 7
RESETN 8
32
MPX
REF3 2
SINC4
FILTER
SIGMA DELTA
CONVERTER
SINC4REG
VDDA 1
RAM
RDS
RDSREG BUFFER
INTN DEMODULATOR &
&
SYNCHRONIZATION
CONTROL
LOGIC
16 MPX
15 INTN
SDAOUT
SDAIN
TEST LOGIC
SCK
I C/SPI
&
INTERFACE SPI
PIN MUX'S
TESTREG
2
14
13
12
11
CSN
SA_DATAOUT
SDA_DATAIN
SCL_CLK
2
10 XTO
OSCILLATOR
9 XTI
CDC-R504MP/X504MP
DGND
SDA
SCL
MUTE
SEL
ADJ
VCC
OUT-FR
OUT-RR
OUT-FL
OUT-RL
BP22
BP12
NC
OUT-SUB-R
OUT-SUB-L
IC401 BD3809FS (MAIN Board)
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
VCC
I2C BUS
LOGIC
FADER
(0~-58,
-∞dB)
VCO
FADER
(0~-58,
-∞dB)
FADER
(0~-58,
-∞dB)
EFFECT (0dB~
+20dB,2dB STEP)
BASS
fo:60,70,80,100,120,140,160,200Hz
Q:0.5,0.75,1,1.25
FADER
(0~-58,
-∞dB)
EFFECT (0dB~
+20dB,2dB STEP)
GAIN+ATT
(+10~-29,
-∞dB)
2ND ORDER LPF
fc:OFF,80,120,160Hz
Q: 0.707
2ND ORDER
LPF
MIX
TONE
PASS
TONE
PASS
MIDDLE
fo:500Hz,1kHz
Q:1
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
TABLE
fo:5,7.5,10,12.5kHz
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
fc:40kHz
fc:40kHz
ANTI-ALIASING
FILTER
ANTI-ALIASING
FILTER
INPUT GAIN
(0~15dB,1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
MUTE
MUTE
INPUT SELECTOR
(4 STEREO INCLUDE 1 ISOLATION INPUT)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
AGND
FIL
AUX-RCH
AN
AUX-LCH
TU-RCH
TU-LCH
CD-RCH
CD-LCH
BUS-RCH
BUS-LCH
BP11
BP21
NC
OUT-SEL-R
OUT-SEL-L
VCC/2
33
CDC-R504MP/X504MP
IC750 TDA8588BJ/N2 (MAIN Board)
TAB 1
2 SDA
OUT-FL- 3
I2C BUS
4 SCL
FL
OUT-FL+ 5
6 VP2
OUT-RL- 7
RL
8 PGND3
OUT-RL+ 9
PROTECTION/
DIAGNOSTIC
IN-RR 15
12 IN-FL
14 IN-FR
MUTE
S-GND 13
10 SVR
MUTE
IN-RL 11
16 BEEP
VP
OUT-RR+ 17
RR
18 PGND2
OUT-RR- 19
20 VP1
OUT-FR+ 21
FR
OUT-FR- 23
STANDBY/
MUTE
22 STB
CHIP DETECT/
DIAGNOSTIC
24 PGND1
BATTERY
DETECTION
DIAG 25
TEMPERATURE
PROTECTION
ENABLE
LOGIC
26 RST
ANT-REM 27
SWITCH
AMP-REM 29
SWITCH
28 CRES
REGULATOR
30 AUDIO8.3V
SERVO5V 31
MECH6V 33
32 GND
34 PANEL+B
VP 35
REFERENCE
VOLTAGE
B.UP+B 37
34
REGULATOR
36 CBU
LOADDUMP
PROTECTION
BACK-UP
SWITCH
CDC-R504MP/X504MP
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this
parts list.
• Abbreviation
CND : Canadian model
4-1. MAIN SECTION
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
A
MG-611MA-186//Q
#2
#1
not supplied
A
7
B
FU601
4
#1
not supplied
5
6
3
#1
not supplied
TU1
not supplied
B
2
#1
#1
1
Ref. No.
Part No.
Description
1
2
3
4
5
X-3384-725-1
3-042-244-11
X-3383-739-1
3-376-464-11
A-3283-529-A
PANEL ASSY, SUB
SCREW (T)
LOCK ASSY (S)
SCREW (+PTT 2.6X6), GROUND POINT
MAIN BOARD, COMPLETE (X504MP:US,CND)
Remark
5
5
6
A-3283-537-A MAIN BOARD, COMPLETE (X504MP:AEP,UK)
A-3283-538-A MAIN BOARD, COMPLETE (R504MP)
3-246-481-01 PLATE (TU), GROUND
Ref. No.
7
7
Part No.
Description
Remark
FU601
TU1
#1
1-776-206-21 CORD (WITH CONNECTOR) (POWER) (US,CND)
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
A-3220-959-A TUNER UNIT (TUX-032//Q)
7-685-792-09 SCREW +PTT 2.6X6 (S)
#2
7-685-790-01 SCREW +PTT 2.6X4 (S)
35
CDC-R504MP/X504MP
4-2. FRONT PANEL SECTION
63
62
not supplied
(KEY board)
#3
59
57
58
#3
56
LCD901
61
60
not supplied
51
not
52 supplied
not
supplied
not supplied
not
supplied
not
supplied
not
supplied
53
55
54
Ref. No.
Part No.
Description
51
51
52
53
54
X-3384-691-1
X-3384-708-1
3-246-479-01
3-262-376-01
3-262-377-01
BUTTON ASSY (S) (X504MP)
BUTTON ASSY (S) (R504MP)
SPRING (RELEASE)
GUIDE (CD), LIGHT
FILTER (IR)
55
55
56
57
3-262-353-21
3-262-353-71
1-780-113-11
3-262-382-01
PANEL, FRONT (X504MP)
PANEL, FRONT (R504MP)
CONDUCTIVE BOARD, CONNECTION
SHEET (LCD), REFLECTION
36
not supplied
Remark
Ref. No.
Part No.
Description
Remark
58
59
60
61
62
3-262-380-01
3-262-374-01
1-861-209-11
3-262-355-01
X-3384-688-1
ILLUMINATOR (LCD)
GUIDE (VOLUME), LIGHT
AUX BOARD
PANEL, FRONT BACK
CASE ASSY (for FRONT PANEL)
63
63
LCD901
#3
A-3372-840-A
A-3372-872-A
1-805-519-11
7-685-106-19
PANEL COMPLETE ASSY, FRONT (X504MP)
PANEL COMPLETE ASSY, FRONT (R504MP)
DISPLAY PANEL, LIQUID CRYSTAL
SCREW +P 2X10 TYPE2 NON-SLIT
CDC-R504MP/X504MP
4-3. CD MECHANISM SECTION (1)
(MG-611MA-186//Q)
102
not supplied
(SENSOR board)
101
109
#4
110
not supplied
not supplied
103
104
106
105
108
107
Ref. No.
Part No.
Description
101
102
103
104
105
A-3372-444-A
3-253-729-11
3-257-892-11
3-257-892-01
3-253-695-11
CHASSIS (T) SUB ASSY
SPRING (LTR), TENSION COIL
SPRING (DAMPER), COIL
SPRING (DAMPER), COIL
SPRING (KF), TENSION COIL
106
3-259-033-01 DAMPER (S)
Remark
Ref. No.
107
108
109
110
#4
Part No.
Description
3-352-758-31
A-3283-357-A
X-3384-088-1
X-3384-089-1
7-627-552-87
SCREW (M1.7), TOOTHED LOCK
SERVO BOARD, COMPLETE
LEVER (L) ASSY
LEVER (R) ASSY
SCREW, PRECISION +P 1.7X2.2
Remark
37
CDC-R504MP/X504MP
(MG-611MA-186//Q)
155
156
157
154
(including M901)
#5
M902
not supplied
SW4
158
not supplied
not supplied
not supplied
153
not supplied
151
152
specified.
Ref. No.
Part No.
Description
151
152
0 153
154
155
A-3372-445-A
3-316-938-91
8-820-207-02
A-3372-448-A
A-3372-449-A
CHASSIS (OP) COMPLETE ASSY
SCREW (B1.4X5), TAPPING
OPTICAL PICK-UP (KSS1000E/K1RP)
CHASSIS (OP) SUB ASSY (including M901)
ARM SUB ASSY, CHUCKING
156
38
A-3372-446-A LEVER (SL) SUB ASSY
Remark
Ref. No.
157
158
M902
SW4
#5
la sécurité.
Part No.
Description
X-3384-090-2
3-264-165-12
A-3372-447-A
1-571-099-11
7-627-850-77
LEVER (SL) ASSY
SCREW
MOTOR ASSY, SL (SLED)
SWITCH (1 KEY) (LIMIT)
SCREW, PRECISION +P 1.4X1.8
Remark
CDC-R504MP/X504MP
(MG-611MA-186//Q)
203
201
202
207
211
204
209
208
210
205
207
207
M903
#4
206
Ref. No.
Part No.
Description
201
202
203
204
205
3-348-993-01
3-259-024-01
A-3372-441-A
3-259-455-11
3-253-713-11
WASHER
WHEEL (RA), WORM
ARM ASSY, ROLLER
SPRING (RAL)
SPRING (RAR)
206
207
3-259-469-11 SPRING (LE), LEAF
2-134-636-21 SCREW (M1.7X2.5)
Remark
Ref. No.
Part No.
Description
208
209
210
211
M903
3-259-467-11
3-345-648-91
A-3372-450-A
3-259-468-11
A-3372-443-A
BRACKET (LEM)
SCREW (M1.4), TOOTHED LOCK
WORM (LEB) ASSY
BEARING (LEB)
MOTOR ASSY, LE (LOADING)
#4
7-627-552-87 SCREW, PRECISION +P 1.7X2.2
Remark
39
CDC-R504MP/X504MP
(MG-611MA-186//Q)
254
252
255
252
256
251
253
257
Ref. No.
251
252
253
254
40
Part No.
Description
3-259-429-11
3-344-223-01
3-259-470-11
3-253-755-11
WHEEL (LE), WORM
WASHER
GEAR (LE1)
LEVER (D)
Remark
Ref. No.
255
256
257
Part No.
Description
3-899-829-01 WASHER (SLIT)
3-259-032-01 GEAR (LE2)
A-3337-998-A CHASSIS (M) BLOCK ASSY
Remark
CDC-R504MP/X504MP
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
• Abbreviation
CND : Canadian model
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
1-861-209-11 AUX BOARD
**********
Ref. No.
JC905
Part No.
AUX
KEY
specified.
la sécurité.
Description
1-216-864-11 METAL CHIP
Remark
0
5%
1/10W
< LIQUID CRYSTAL DISPLAY >
< JACK >
LCD901 1-805-519-11 DISPLAY PANEL, LIQUID CRYSTAL
J601
1-817-308-11 JACK (AUX IN)
*************************************************************
KEY BOARD
**********
SML310BA1TT86 (MENU)
SML310BA1TT86 (OFF)
SML310BA1TT86
(+ > M, m . –)
LED905 6-500-476-01 LED SML310BA1TT86 (1)
1-780-113-11 CONDUCTIVE BOARD, CONNECTION
3-262-380-01 ILLUMINATOR (LCD)
3-262-382-01 SHEET (LCD), REFLECTION
< CAPACITOR >
C901
C902
C903
C904
C905
1-162-968-11
1-162-968-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0047uF
0.0047uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
16V
16V
16V
C906
C971
C991
C992
C993
1-107-826-11
1-115-156-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
1uF
0.1uF
0.1uF
0.1uF
10%
16V
10V
16V
16V
16V
C994
C995
C996
1-162-964-11 CERAMIC CHIP
0.001uF
0.22uF
1uF
10%
10%
10%
10%
10%
50V
16V
10V
< CONNECTOR >
CN901
< DIODE >
LED901
LED902
LED903
LED904
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
LED
LED
LED
LED
LED906
LED907
LED908
LED909
LED910
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
LED
LED
LED
LED
LED
SML310BA1TT86 (PTY,AF/TA)
SML310BA1TT86 (4)
SML310BA1TT86 (3)
LED911
LED912
LED913
LED914
LED915
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
LED
LED
LED
LED
LED
SML310BA1TT86 (2)
SML310BA1TT86 (5)
SML310BA1TT86 (6)
SML310BA1TT86 (ATT)
SML310BA1TT86 (EQ)
LED916
LED917
LED918
LED919
LED920
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
6-500-476-01
LED
LED
LED
LED
LED
SML310BA1TT86 (DSPL)
SML310BA1TT86 (H-BASS)
SML310BA1TT86 (BTM/SENS)
SML310BA1TT86 (SOURCE,MODE)
SML310BA1TT86 (Z)
LED921 6-500-855-01 LED CL-490S-WF-SD-TS (LCD BACK LIGHT)
LED922 6-500-855-01 LED CL-490S-WF-SD-TS (LCD BACK LIGHT)
1-817-332-11 PLUG, CONNECTOR 15P
< TRANSISTOR >
< DIODE >
Q901
D901
D902
D904
D991
D992
6-500-886-01
8-719-978-33
8-719-978-33
8-719-069-54
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
RSA6.1ENTR
DTZ-TT11-6.8B
DTZ-TT11-6.8B
UDZS-TE17-5.1B
MA111-TX
< RESISTOR >
< IC >
IC901
IC971
6-705-180-01 IC LC75827W
6-600-163-01 IC RS-770 (IR)
< JUMPER RESISTOR >
JC903
1-216-864-11 METAL CHIP
0
8-729-120-28 TRANSISTOR 2SC1623-L5L6
5%
1/10W
R901
R902
R903
R904
R905
1-216-194-00
1-216-819-11
1-216-194-00
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
680
680
5%
5%
5%
5%
5%
1/8W
1/10W
1/8W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-821-11
1-216-823-11
1-216-823-11
1-216-825-11
1-216-194-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1.5K
1.5K
2.2K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
41
CDC-R504MP/X504MP
KEY
Ref. No.
MAIN
Part No.
Description
R911
R912
R913
R914
R915
1-216-819-11
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
1K
1.5K
1.5K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R916
R917
R918
R919
R920
1-216-825-11
1-216-827-11
1-218-867-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
6.8K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
R922
R931
R932
R933
1-216-017-00
1-216-295-11
1-216-033-00
1-216-033-00
1-216-033-00
RES-CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
0
220
220
220
5%
1/10W
A-3283-529-A MAIN BOARD, COMPLETE (X504MP:US,CND)
A-3283-537-A MAIN BOARD, COMPLETE (X504MP:AEP,UK)
A-3283-538-A MAIN BOARD, COMPLETE (R504MP)
*********************
5%
5%
5%
1/10W
1/10W
1/10W
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT
7-685-793-09 SCREW +PTT 2.6X8 (S)
7-685-795-09 SCREW +PTT 2.6X12 (S)
R934
R935
R936
R937
R938
1-216-033-00
1-216-033-00
1-216-033-00
1-216-033-00
1-216-033-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R939
R940
R950
R951
R952
1-216-033-00
1-216-033-00
1-216-808-11
1-216-821-11
1-216-824-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
82
1K
1.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R953
R971
R972
R981
R982
1-216-824-11
1-216-049-11
1-216-821-11
1-216-295-11
1-216-295-11
METAL CHIP
RES-CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
1.8K
1K
1K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
R983
R984
R985
R986
R987
1-216-295-11
1-216-801-11
1-216-801-11
1-216-801-11
1-216-811-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22
22
22
150
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R988
R991
R992
R993
R994
1-216-811-11
1-216-864-11
1-216-840-11
1-216-857-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
0
39K
1M
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R995
R996
1-216-827-11 METAL CHIP
1-216-827-11 METAL CHIP
3.3K
3.3K
5%
5%
1/10W
1/10W
S915
S916
S917
S918
S919
Part No.
Description
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (ATT)
SWITCH, TACTILE (MODE)
SWITCH, TACTILE (BTM/SENS)
SWITCH, TACTILE (6/ALBUM +)
SWITCH, TACTILE (5/ALBUM –)
Remark
S920
1-771-884-31 SWITCH, TACTILE (4/SHUF)
*************************************************************
< CAPACITOR >
C1
0.001uF
10%
C2
0.001uF
10%
C3
1-126-963-11 ELECT
4.7uF
20%
C4
C5
1-126-947-11 ELECT
1-126-947-11 ELECT
47uF
47uF
20%
20%
C6
C7
C8
C9
C51
1-162-970-11
1-164-230-11
1-164-230-11
1-162-970-11
1-126-947-11
0.01uF
220PF
220PF
0.01uF
47uF
10%
5%
5%
10%
20%
25V
50V
50V
25V
16V
(R504MP)
C52
0.1uF
10%
C53
0.1uF
10%
C54
0.1uF
10%
C55
0.1uF
10%
C56
0.1uF
10%
16V
(R504MP)
16V
(R504MP)
16V
(R504MP)
16V
(R504MP)
16V
(R504MP)
C57
0.1uF
10%
C58
0.1uF
10%
< SWITCH >
C59
18PF
5%
C60
18PF
5%
C62
330PF
5%
C301
C302
C303
C304
C305
1-128-551-11
1-128-551-11
1-128-551-11
1-104-665-11
1-164-230-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
22uF
22uF
22uF
100uF
220PF
20%
20%
20%
20%
5%
25V
25V
25V
10V
50V
C307
C308
C309
C310
C333
1-164-230-11
1-128-551-11
1-164-230-11
1-164-230-11
1-163-251-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
22uF
220PF
220PF
100PF
5%
20%
5%
5%
5%
50V
25V
50V
50V
50V
S901
S902
S903
S904
S905
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (Z)
SWITCH, TACTILE (OFF)
SWITCH, TACTILE (SOURCE)
SWITCH, TACTILE (3/REP)
SWITCH, TACTILE (2)
S906
S907
S908
S909
S910
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (1)
SWITCH, TACTILE (AF/TA)
SWITCH, TACTILE (PTY)
SWITCH, TACTILE (SEEK m . –)
SWITCH, TACTILE (SEEK + > M)
S911
S912
S913
S914
1-478-474-11
1-771-884-31
1-771-884-31
1-771-884-31
ENCODER, ROTARY (VOLUME,PUSH-MENU)
SWITCH, TACTILE (DSPL)
SWITCH, TACTILE (H-BASS)
SWITCH, TACTILE (EQ)
42
Ref. No.
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
50V
(R504MP)
50V
(R504MP)
50V
(R504MP)
16V
16V
16V
(R504MP)
16V
(R504MP)
50V
(R504MP)
50V
(R504MP)
50V
(R504MP)
CDC-R504MP/X504MP
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C334
C401
C402
C403
C404
1-163-251-11
1-125-837-11
1-125-837-11
1-127-715-11
1-127-715-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
1uF
1uF
0.22uF
0.22uF
5%
10%
10%
10%
10%
50V
6.3V
6.3V
16V
16V
C624
C625
C626
C627
C628
1-164-161-11
1-164-161-11
1-164-161-11
1-164-161-11
1-164-161-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.0022uF
0.0022uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
100V
100V
100V
100V
100V
C405
C406
C407
C408
C409
1-126-960-11
1-126-960-11
1-126-964-11
1-127-715-11
1-127-715-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
10uF
0.22uF
0.22uF
20%
20%
20%
10%
10%
50V
50V
50V
16V
16V
C629
C630
C631
C632
C701
1-164-161-11
1-164-161-11
1-164-161-11
1-126-961-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0022uF
0.0022uF
0.0022uF
2.2uF
0.1uF
10%
10%
10%
20%
100V
100V
100V
50V
25V
C410
C411
C412
C415
C416
1-127-715-11
1-127-715-11
1-126-947-11
1-125-837-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.22uF
47uF
1uF
1uF
10%
10%
20%
10%
10%
16V
16V
16V
6.3V
6.3V
C703
C704
C731
C732
C750
1-164-156-11
1-126-934-11
1-162-965-11
1-162-965-11
1-115-340-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220uF
0.0015uF
0.0015uF
0.22uF
20%
10%
10%
10%
25V
10V
50V
50V
25V
C419
C420
C425
C426
C427
1-162-966-11
1-162-966-11
1-164-156-11
1-164-156-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF 10%
0.0022uF 10%
0.1uF
0.1uF
0.01uF
10%
50V
50V
25V
25V
25V
C751
C753
C754
C755
C756
1-115-340-11
1-128-551-11
1-126-961-11
1-162-923-11
1-127-715-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.22uF
22uF
2.2uF
47PF
0.22uF
10%
20%
20%
5%
10%
25V
25V
50V
50V
16V
C428
C429
C430
C431
C432
1-164-156-11
1-164-156-11
1-125-889-11
1-126-964-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
2.2uF
10uF
0.47uF
10%
20%
10%
25V
25V
10V
50V
10V
C758
C759
C760
C761
C764
1-126-964-11
1-126-964-11
1-104-665-11
1-126-964-11
1-165-822-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
100uF
10uF
1uF
20%
20%
20%
20%
50V
50V
10V
50V
25V
C441
C442
C451
C452
C461
1-126-964-11
1-125-891-11
1-126-964-11
1-125-891-11
1-126-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.47uF
10uF
0.47uF
10uF
20%
10%
20%
10%
20%
50V
10V
50V
10V
50V
C765
C766
C462
C471
C481
C491
C492
1-125-891-11
1-126-964-11
1-126-964-11
1-126-947-11
1-107-826-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.47uF
10uF
10uF
47uF
0.1uF
10%
20%
20%
20%
10%
10V
50V
50V
16V
16V
C501
C502
C503
C504
C507
1-162-970-11
1-162-964-11
1-104-665-11
1-162-970-11
1-162-917-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
100uF
0.01uF
15PF
10%
10%
20%
10%
5%
25V
50V
10V
25V
50V
C508
C509
C510
C511
C512
1-162-917-11
1-162-966-11
1-162-970-11
1-126-947-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
15PF
0.0022uF
0.01uF
47uF
0.001uF
5%
10%
10%
20%
10%
50V
50V
25V
16V
50V
C513
C514
C515
C516
1-162-970-11
1-162-964-11
1-164-315-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
470PF
0.001uF
10%
10%
5%
10%
C517
0.001uF
10%
C601
C602
C617
C618
C621
1-131-868-81
1-165-319-11
1-163-009-11
1-163-009-11
1-107-826-11
3300uF
0.1uF
0.001uF
0.001uF
0.1uF
20%
C622
C623
1-125-710-11 DOUBLE LAYERS 0.1F
1-104-665-11 ELECT
100uF
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
Remark
25V
50V
50V
50V
(R504MP)
50V
10%
10%
10%
16V
50V
50V
50V
16V
20%
5.5V
10V
Ref. No.
Remark
1uF
1uF
25V
25V
< CONNECTOR >
CN301
CN601
CN701
1-817-536-11 CONNECTOR, BOARD TO BOARD 28P
1-774-701-21 PIN, CONNECTOR 16P
1-817-333-11 SOCKET, CONNECTOR 15P
< DIODE >
D1
D301
D401
D402
D491
8-719-069-55
8-719-041-79
8-719-062-51
6-500-697-01
8-719-069-55
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE17-5.6B
MA721WA-TX
1PS226-115
UDZS-TE17-3.3B
UDZS-TE17-5.6B
D492
D503
D580
D581
D586
8-719-404-50
8-719-040-04
8-719-056-84
8-719-083-66
8-719-050-84
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA721WK-(TX)
UDZ-TE-17-7.5B
UDZS-TE17-18B
RB441Q-40T-77
D587
D601
D609
D651
D702
8-719-050-84
8-719-049-38
8-719-978-33
8-719-083-66
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
RB441Q-40T-77
1N5404TU
DTZ-TT11-6.8B
UDZS-TE17-18B (AEP,UK)
RD6.8ES-B2
D703
D711
D712
D731
D751
8-719-109-97
6-500-886-01
6-500-886-01
8-719-062-51
8-719-970-02
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
RSA6.1ENTR
RSA6.1ENTR
1PS226-115
1SR139-400
D752
D753
D754
D755
8-719-970-02
8-719-970-02
8-719-970-02
8-719-970-02
DIODE
DIODE
DIODE
DIODE
1SR139-400
1SR139-400
1SR139-400
1SR139-400
43
CDC-R504MP/X504MP
MAIN
Ref. No.
Part No.
Description
Part No.
Description
D756
D757
D758
D759
D760
8-719-970-02
8-719-970-02
8-719-970-02
8-719-970-02
8-719-970-02
DIODE
DIODE
DIODE
DIODE
DIODE
1SR139-400
1SR139-400
1SR139-400
1SR139-400
1SR139-400
Remark
Q51
Q52
Q401
Q402
Q403
8-729-027-23
8-729-027-43
8-729-422-33
8-729-027-23
8-729-035-74
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114EKA-T146 (R504MP)
DTC114EKA-T146 (R504MP)
2SD601A-Q-TX
DTA114EKA-T146
FMG4AT148
D761
D762
8-719-970-02 DIODE 1SR139-400
8-719-970-02 DIODE 1SR139-400
Q431
Q441
Q451
Q461
Q471
6-550-752-01
6-550-752-01
6-550-752-01
6-550-752-01
6-550-752-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC614TKT146
DTC614TKT146
DTC614TKT146
DTC614TKT146
DTC614TKT146
Q481
Q491
Q492
Q503
Q580
6-550-752-01
8-729-027-43
8-729-027-23
8-729-027-23
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC614TKT146
DTC114EKA-T146
DTA114EKA-T146
DTA114EKA-T146
DTC114EKA-T146
Q581
Q582
Q631
Q651
1-801-806-11
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC144EKA
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6 (AEP,UK)
< IC >
IC51
IC401
IC501
IC602
IC750
6-803-747-01
6-705-518-01
6-804-065-01
8-759-659-13
6-705-360-01
IC
IC
IC
IC
IC
TDA7333-013TR (R504MP)
BD3809FS-FE2
MN101E01KSH
PST3428UL
TDA8588BJ/N2
Ref. No.
Remark
< JACK >
J1
J331
1-815-185-13 JACK (ANTENNA)
1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR)
< JUMPER RESISTOR >
< RESISTOR >
JC2
JC6
JC7
JC10
JC11
1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R1
R4
R5
R6
1-216-821-11
1-216-839-11
1-216-843-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
33K
68K
33K
5%
5%
5%
5%
JC13
JC14
JC17
JC18
JC19
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
5%
1/10W
R7
1-216-843-11 METAL CHIP
68K
5%
R7
1-216-845-11 METAL CHIP
100K
5%
R8
1-216-839-11 METAL CHIP
33K
5%
JC20
JC22
JC24
JC25
JC26
1-216-864-11
1-216-864-11
1-216-296-11
1-216-864-11
1-216-296-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
0
0
0
0
0
5%
5%
1/10W
1/10W
R9
1-216-843-11 METAL CHIP
68K
5%
5%
1/10W
R9
1-216-845-11 METAL CHIP
100K
5%
R10
1-216-809-11 METAL CHIP
100
5%
R15
R16
R51
R52
R53
1-216-809-11
1-216-809-11
1-414-595-11
1-414-595-11
1-216-801-11
R54
1-216-833-11 METAL CHIP
R55
1-216-864-11
R56
R57
R58
1-414-595-11
1-414-595-11
1-216-864-11
R59
< COIL >
L1
L302
L303
L304
L305
1-469-844-11
1-469-876-11
1-469-876-11
1-500-245-11
1-500-245-11
INDUCTOR
2.2uH
INDUCTOR, FERRITE BEAD
L306
L307
L308
L309
L310
1-500-245-11
1-469-876-11
1-469-876-11
1-500-245-11
1-469-876-11
L372
L373
L374
L501
L502
1-469-876-11
1-500-245-11
1-500-245-11
1-216-864-11
1-500-245-11
METAL CHIP
0
L601
L731
1-456-617-11 COIL, CHOKE
1-410-509-11 INDUCTOR
5%
44
1/10W
(X504MP)
1/10W
(R504MP)
1/10W
(R504MP)
1/10W
(X504MP)
1/10W
(R504MP)
METAL CHIP
100
5%
1/10W
METAL CHIP
100
5%
1/10W
INDUCTOR, FERRITE BEAD (R504MP)
METAL CHIP
22
5%
1/10W
(R504MP)
10K
5%
1/10W
(R504MP)
METAL CHIP
0
5%
1/10W
(R504MP)
METAL CHIP
0
5%
1/10W
(R504MP)
1-216-797-11 METAL CHIP
10
5%
R61
1-216-864-11 METAL CHIP
0
5%
R303
R401
R402
1-216-296-11 SHORT CHIP
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
0
2.2K
2.2K
5%
5%
1/10W
1/10W
R405
1-218-881-11 METAL CHIP
27K
0.5%
1/10W
1/10W
250uH
10uH
< TRANSISTOR >
Q1
Q3
1/10W
1/10W
1/10W
1/10W
(R504MP)
1/10W
(R504MP)
8-729-106-68 TRANSISTOR 2SD1615A-GP
8-729-027-43 TRANSISTOR DTC114EKA-T146 (R504MP)
1/10W
(R504MP)
1/10W
(R504MP)
CDC-R504MP/X504MP
MAIN
Ref. No.
Part No.
Description
R406
R407
R408
R409
R410
1-216-811-11
1-216-811-11
1-216-811-11
1-216-811-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
150
150
150
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R411
R413
R414
R415
R416
1-216-809-11
1-216-845-11
1-216-845-11
1-216-857-11
1-216-832-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
100K
1M
8.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R417
R418
R419
R428
R429
1-216-827-11
1-216-833-11
1-216-857-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
10K
1M
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R431
R432
R433
R441
R442
1-216-809-11
1-216-841-11
1-216-864-11
1-216-809-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
0
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R443
R451
R452
R453
R461
1-216-864-11
1-216-809-11
1-216-841-11
1-216-864-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
47K
0
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R462
R463
R471
R472
R481
1-216-841-11
1-216-864-11
1-216-809-11
1-216-841-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
0
100
47K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R482
R491
R492
R493
R501
1-216-841-11
1-216-857-11
1-216-864-11
1-216-805-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1M
0
47
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R502
R503
R504
R505
R506
1-216-809-11
1-216-809-11
1-218-871-11
1-218-871-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10K
10K
100K
5%
5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R508
R509
R510
R511
R512
1-216-813-11
1-216-864-11
1-216-801-11
1-216-801-11
1-216-801-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
0
22
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R513
R514
R518
R520
R521
1-216-845-11
1-216-845-11
1-249-417-11
1-216-845-11
1-216-825-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
100K
100K
1K
100K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/10W
1/10W
R522
R528
R530
R531
R532
1-216-825-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R534
R535
1-216-833-11 METAL CHIP
1-216-845-11 METAL CHIP
10K
100K
5%
5%
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R537
1-216-845-11 METAL CHIP
100K
5%
R538
1-216-845-11 METAL CHIP
100K
5%
R539
R540
R541
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-845-11 METAL CHIP
0
0
100K
5%
5%
5%
R543
R544
R547
R549
1-216-845-11
1-216-821-11
1-216-864-11
1-216-845-11
100K
1K
0
100K
R551
1-216-845-11 METAL CHIP
R552
R556
R557
R558
1-216-864-11
1-216-864-11
1-216-809-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
100
100K
5%
5%
5%
5%
R559
1-216-845-11 METAL CHIP
100K
5%
R560
1-216-845-11 METAL CHIP
100K
5%
R563
R564
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
5%
5%
R565
R566
1-216-809-11 METAL CHIP
1-218-871-11 METAL CHIP
100
10K
5%
0.5%
R567
1-216-833-11 METAL CHIP
10K
5%
R573
R579
R582
R583
1-216-864-11
1-216-809-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
1K
1K
5%
5%
5%
5%
R584
R585
R591
R592
1-216-849-11
1-216-849-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
100
0
5%
5%
5%
5%
R593
1-216-864-11 METAL CHIP
0
5%
1/10W
1/10W
1/10W
1/10W
(R504MP)
1/10W
R595
R596
R609
R631
R632
1-216-833-11
1-216-864-11
1-249-417-11
1-249-425-11
1-216-841-11
METAL CHIP
METAL CHIP
CARBON
CARBON
METAL CHIP
10K
0
1K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/10W
R633
R634
R636
R651
1-216-841-11
1-216-829-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
4.7K
100K
1K
5%
5%
5%
5%
R652
1-249-437-11 CARBON
47K
5%
1/10W
1/10W
1/10W
1/10W
(AEP,UK)
1/4W
(AEP,UK)
R653
1-216-833-11 METAL CHIP
10K
5%
R654
R701
R731
R732
1-216-833-11
1-249-401-11
1-249-417-11
1-249-417-11
METAL CHIP
CARBON
CARBON
CARBON
10K
47
1K
1K
5%
5%
5%
5%
1/10W
(AEP,UK)
1/10W
1/4W
1/4W
1/4W
R733
R734
R735
1-216-834-11 METAL CHIP
1-216-834-11 METAL CHIP
1-216-820-11 METAL CHIP
12K
12K
820
5%
5%
5%
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1/10W
(X504MP)
1/10W
(R504MP)
1/10W
1/10W
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
(X504MP:AEP,UK)
100K
5%
1/10W
(R504MP/X504MP:US,CND)
1/10W
1/10W
1/10W
1/10W
(X504MP)
1/10W
1/10W
(US,CND)
1/10W
1/10W
(AEP,UK)
1/10W
1/10W
1/10W
(R504MP)
1/10W
1/10W
1/10W
1/10W
45
CDC-R504MP/X504MP
MAIN
Ref. No.
R752
R756
SENSOR
Part No.
SERVO
Description
1-216-809-11 METAL CHIP
1-216-841-11 METAL CHIP
100
47K
5%
5%
Remark
Ref. No.
Part No.
Description
1/10W
1/10W
C38
C39
C40
C41
C42
1-107-826-11
1-162-927-11
1-162-969-11
1-164-156-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
0.0068uF
0.1uF
0.01uF
10%
5%
10%
10%
16V
50V
25V
25V
25V
C43
C44
C45
C46
C47
1-125-837-11
1-162-970-11
1-162-970-11
1-162-965-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
0.01uF
0.0015uF
0.1uF
10%
10%
10%
10%
10%
6.3V
25V
25V
50V
16V
C48
C49
C50
C51
C52
1-104-609-11
1-125-837-11
1-125-837-11
1-164-156-11
1-100-381-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
100uF
1uF
1uF
0.1uF
10uF
20%
10%
10%
4V
6.3V
6.3V
25V
16V
C53
C54
C55
C56
C57
1-100-381-11
1-164-156-11
1-164-156-11
1-162-970-11
1-164-156-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.1uF
0.01uF
0.1uF
20%
C58
C59
C60
C63
C64
1-107-826-11
1-107-826-11
1-100-381-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.01uF
0.1uF
10%
10%
20%
10%
10%
16V
16V
16V
25V
16V
C65
C66
C67
C74
C75
1-126-208-21
1-164-156-11
1-107-826-11
1-126-208-21
1-162-970-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47uF
0.1uF
0.1uF
47uF
0.01uF
20%
10%
20%
10%
4V
25V
16V
4V
25V
C77
C79
C81
C83
C85
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
6.3V
C86
C91
C92
C107
C109
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C110
C115
0.1uF
10%
0.0022uF 10%
16V
50V
< SWITCH >
S702
1-692-431-21 SWITCH, TACTILE (RESET)
< TUNER >
TU1
Remark
A-3220-959-A TUNER UNIT (TUX-032//Q)
< VIBRATOR >
X51
1-813-173-11 VIBRATOR, CRYSTAL (8.664MHz) (R504MP)
X501
1-813-160-11 VIBRATOR, CERAMIC (27MHz)
X502
1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
SENSOR BOARD
**************
< SWITCH >
SW2
1-529-566-61 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
A-3283-357-A SERVO BOARD, COMPLETE
**********************
< CAPACITOR >
C1
C2
C3
C4
C5
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
16V
C6
C7
C8
C10
C11
1-162-970-11
1-162-962-11
1-162-962-11
1-104-609-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
470PF
470PF
100uF
0.1uF
10%
10%
10%
20%
10%
25V
50V
50V
4V
16V
C13
C14
C16
C18
C19
1-162-965-11
1-162-965-11
1-107-826-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0015uF
0.1uF
0.022uF
0.022uF
10%
10%
10%
10%
10%
50V
50V
16V
25V
25V
C21
C22
C23
C24
C25
1-107-826-11
1-162-962-11
1-162-967-11
1-162-962-11
1-162-967-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
0.0033uF
470PF
0.0033uF
10%
10%
10%
10%
10%
16V
50V
50V
50V
50V
C26
C27
C28
C29
C30
1-162-970-11
1-126-208-21
1-107-826-11
1-164-156-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
25V
4V
16V
25V
16V
C32
C33
C34
C35
C36
1-164-156-11
1-164-156-11
1-107-826-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
25V
25V
16V
16V
25V
C37
0.033uF
10%
16V
46
20%
10%
16V
25V
25V
25V
25V
< CONNECTOR >
CN1
CN2
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-817-275-21 CONNECTOR, BOARD TO BOARD 28P
< JUMPER RESISTOR >
FB1
FB2
FB5
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
0
5%
5%
5%
< IC >
IC1
IC3
IC4
IC7
IC8
6-705-366-01
8-753-216-86
6-804-028-01
6-705-364-01
6-705-365-01
IC
IC
IC
IC
IC
LA6560-TE-L-E
CXD3059BR
MB90487PFV-G-105-BNDE1
R1114N151D-TR-FA
TC94A34FG-002
1/10W
1/10W
1/10W
CDC-R504MP/X504MP
SERVO
Ref. No.
Part No.
Description
Remark
< TRANSISTOR >
Q1
Q2
Q3
Q5
Q6
8-729-904-87
8-729-928-90
8-729-904-87
8-729-904-87
8-729-928-90
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1197K-R
DTC114EE
2SB1197K-R
2SB1197K-R
DTC114EE
< RESISTOR >
R1
R2
R3
R4
R5
1-218-941-81
1-218-971-11
1-218-971-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
33K
33K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R6
R7
R8
R9
R10
1-218-965-11
1-208-635-11
1-218-971-11
1-218-971-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10
33K
33K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R11
R12
R13
R14
R15
1-218-965-11
1-208-635-11
1-218-965-11
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
10K
10
10K
0
0
5%
5%
5%
1/16W
1/16W
1/16W
R16
R17
R18
R19
R20
1-218-990-11
1-218-965-11
1-218-965-11
1-218-969-11
1-218-969-11
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
10K
10K
22K
22K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R21
R22
R23
R24
R25
1-218-990-11
1-218-967-11
1-218-967-11
1-218-953-11
1-218-953-11
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
15K
15K
1K
1K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R26
R27
R28
R29
R37
1-218-981-11
1-218-965-11
1-218-990-11
1-218-977-11
1-218-947-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
220K
10K
0
100K
330
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R38
R39
R40
R41
R42
1-218-967-11
1-218-941-81
1-218-990-11
1-218-985-11
1-218-965-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
15K
100
0
470K
10K
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R43
R44
R45
R46
R47
1-218-977-11
1-218-957-11
1-218-971-11
1-218-957-11
1-218-977-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
2.2K
33K
2.2K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R48
R49
R50
R52
R53
1-218-941-81
1-218-953-11
1-218-941-81
1-218-941-81
1-218-959-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
1K
100
100
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R54
R55
R56
R57
R59
1-218-961-11
1-218-953-11
1-218-973-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
1K
47K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
R60
R61
R62
R64
R65
1-218-990-11
1-218-985-11
1-218-965-11
1-218-941-81
1-218-941-81
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
470K
10K
100
100
Remark
R67
R68
R69
R70
R71
1-218-941-81
1-218-990-11
1-218-973-11
1-218-945-11
1-218-941-81
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
0
47K
220
100
R72
R73
R74
R76
R77
1-218-990-11
1-218-941-81
1-218-941-81
1-218-941-81
1-218-990-11
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
R78
R79
R80
R81
R85
1-218-941-81
1-218-941-81
1-218-977-11
1-218-941-81
1-218-973-11
R86
R87
R91
R92
R97
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
0
100
100
100
0
5%
5%
5%
1/16W
1/16W
1/16W
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100K
100
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1-218-973-11
1-218-973-11
1-220-200-81
1-218-971-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
47K
30K
33K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R98
R99
R101
R106
R107
1-218-941-81
1-218-965-11
1-218-969-11
1-218-969-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
10K
22K
22K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R108
R109
R110
R111
R114
1-218-941-81
1-218-953-11
1-218-945-11
1-218-990-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
100
1K
220
0
100
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R115
R116
R117
R119
R122
1-218-941-81
1-218-941-81
1-218-990-11
1-218-941-81
1-218-965-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
100
100
0
100
10K
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R123
R124
R126
R127
R128
1-218-990-11
1-216-864-11
1-218-965-11
1-218-965-11
1-218-965-11
SHORT CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
0
10K
10K
10K
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
R129
R133
R136
R139
R140
1-218-965-11
1-216-864-11
1-218-977-11
1-218-957-11
1-218-941-81
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
0
100K
2.2K
100
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R141
R142
R143
R144
R145
1-218-941-81
1-218-941-81
1-218-941-81
1-218-965-11
1-218-977-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
10K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R146
R147
R148
1-218-941-81 RES-CHIP
1-218-941-81 RES-CHIP
1-218-941-81 RES-CHIP
100
100
100
5%
5%
5%
1/16W
1/16W
1/16W
47
CDC-R504MP/X504MP
SERVO
Ref. No.
R149
Part No.
Description
1-218-941-81 RES-CHIP
Remark
100
5%
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
1/16W
< SWITCH >
SW1
1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN)
< VIBRATOR >
X1
1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz)
X2
1-795-822-21 VIBRATOR, CERAMIC (18.43MHz)
*************************************************************
MISCELLANEOUS
***************
7
7
301
302
303
304
305
X-3382-647-1
X-3382-926-1
3-349-410-11
3-934-325-01
3-262-387-11
306
307
308
1-465-459-31 ADAPTOR, ANTENNA (AEP,UK)
3-246-471-01 KEY (FRAME)
(AEP,UK)
309
FRAME ASSY, FITTING
SCREW ASSY (BS), FITTING (AEP,UK)
BUSHING (AEP,UK)
SCREW, +K (5X8) TAPPING (US,CND)
COLLAR
(AEP,UK)
8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP)
A-3372-448-A CHASSIS (OP) SUB ASSY (including M901)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
301
M902
A-3372-447-A MOTOR ASSY, SL (SLED)
M903
A-3372-443-A MOTOR ASSY, LE (LOADING)
SW4
1-571-099-11 SWITCH (1 KEY) (LIMIT)
*************************************************************
304
305
306
307
308
309
0 153
154
FU601
ACCESSORIES
************
302
303
1-476-526-51 REMOTE COMMANDER (RM-Z304)
3-230-047-01 LID, BATTERY CASE (for RM-Z304)
3-263-359-11 MANUAL, INSTRUCTION, FITTING (ENGLISH,
FRENCH,SPANISH) (US,CND)
3-263-363-11 MANUAL, INSTRUCTION, FITTING (ENGLISH,
GERMAN,FRENCH,ITALIAN,DUTCH)
(AEP,UK)
3-263-363-21 MANUAL, INSTRUCTION, FITTING (SPANISH,
POLISH,CZECH,HUNGARIAN,RUSSIAN)
(AEP,UK)
3-263-367-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,
SPANISH) (US,CND)
3-263-369-11 MANUAL, INSTRUCTION (ENGLISH,GERMAN,
FRENCH,ITALIAN,DUTCH,SPANISH,
(X504MP:AEP,UK)
3-263-370-11 MANUAL, INSTRUCTION (ENGLISH,GERMAN,
FRENCH,ITALIAN,DUTCH,SPANISH,
(R504MP)
X-3384-688-1 CASE ASSY (for FRONT PANEL)
*************************************************************
48
specified.
la sécurité.
CDC-R504MP/X504MP
MEMO
49
CDC-R504MP/X504MP
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.
Ver.
1.0
50
Date
2004. 01
Description of Revision
New

Aiwa CDC-R504MP, CDC-X504MP Service manual. www.s

Transcription

Similar documents

CDX-GT800D/GT805DX

service manual

CDX-M700R/M750

CDX-R3000/RW300

CDX-C90 -- Service Manual

PDF Preisliste DISTRI 2602

STR-DA30ES/DA50ES/V55ES

ICF-SW55

service manual - [email protected]

FY8-31DY-01Y