Stiebel Eltron Ultronic Hand Dryer Installation

Transcription

OPERATION AND INSTALLATION MANUAL
GUÍA DE OPERACIÓN E INSTALACIÓN
MODE D’EMPLOI ET MANUEL D’INSTALLATION
TOUCHLESS AUTOMATIC HIGH-SPEED HAND DRYERS
SECADORES DE MANO DE ALTA VELOCIDAD SIN CONTACTO
SÉCHOIRS DE MAIN SANS CONTACT AUTOMATIQUES ET ULTRA RAPIDES
»
»
»
»
ULTRONIC™
ULTRONIC™
ULTRONIC™
ULTRONIC™
1S
1W
2S
2W
STIEBEL ELTRON, Inc.
17 West Street | West Hatfield, MA 01088
Tel. 413-247-3380 | Fax 413-247-3369
Email [email protected]
www.stiebel-eltron-usa.com
Simply the Best
HandDryerSupply.com | 804-859-2498 | [email protected]
CONTENTS | OPERATION
OPERATION
1.
Important instructions __________________________ 3
1.1 Symbol key_____________________________________________3
1.2 Symbols in this document _________________________3
2.
3.
4.
4.1
4.2
Safety precautions ______________________________ 4
Register your product ___________________________ 5
Instructions for the end user ___________________ 5
General use information ____________________________5
User servicing instructions__________________________5
INSTALLATION
5.
Installation instructions for the licensed
installer __________________________________________ 6
6.
7.
Minimum clearances ____________________________ 6
Mounting the unit _______________________________ 7
7.1
7.2
Recommended mounting heights ____________ 7
Wall mounting ___________________________________ 7
8.
Electrical connections ___________________________ 8
9.
Dimensions _______________________________________ 9
10.
Technical data ___________________________________ 9
11.
12.
13.
Warranty ________________________________________ 10
Environment and recycling ____________________ 10
Wall-mounting template _______________________ 29
2 | ULTRONIC™ 1 / ULTRONIC™ 2 TOUCHLESS AUTOMATIC HAND DRYERS
WWW.STIEBEL-ELTRON-USA.COM
GENERAL INFORMATION
IMPORTANT INSTRUCTIONS
1.1.2 Symbols
Important Instructions
Read this entire manual. Failure to follow all the
guides, instructions and rules could cause personal
injury or property damage. Improper installation,
adjustment, alteration, service and use of this unit can
result in serious injury.
This unit must be installed by a licensed electrician and
plumber. The installation must comply with all national,
state and local electric codes. Proper installation is the
responsibility of the installer. Failure to comply with
the installation and operating instructions or improper
use voids the warranty.
Save
 these instructions for future reference.
Installer should leave these instructions with the
consumer.
If you have any questions regarding the installation,
use or operation of this hand dryer, or if you need
any additional installation manuals, please call our
technical service line at 800-582-8423 (USA and Canada
only). If you are calling from outside the USA or Canada,
please call USA 413-247-3380 and we will refer you to
a qualified Stiebel Eltron service representative in your
area.
This is the safety alert symbol. It is used to alert
you to potential personal injury hazard. Obey
all safety messages that follow this symbol to avoid
possible injury or death.
!
Symbol
Description
Injury
Electrocution
Burns or scalding
Other situations
!
1.1.3 Keywords
KEYWORD
DANGER
WARNING
CAUTION
1.2
The keyword DANGER indicates
information that must be observed,
otherwise serious injury or death
will result.
The keyword WARNING indicates
otherwise serious injury or death
may result.
The keyword CAUTION indicates
otherwise relatively serious or light
injuries may result.
Symbols in this document
The chapter Operation is intended for homeowners,
heating contractors, plumbers and electricians.
The chapter Installation is intended for heating
contractors, plumbers and electricians only.
This
 symbol ( 
) indicates that you must do
something. The necessary actions are indicated in a
step-by-step fashion.
1.1
General Information
This is the general information icon.
Please

read and pay careful attention to all general
Symbol key
1.1.1 Layout of safety information
1
2
DANGER Electric shock
Before any work on the appliance,
disconnect all poles from
o m the
t e
th
power supply.
1
2
3
4
information notes.
3
4
Symbol (see 1.1.2 "Symbols")
Keyword (see 1.1.3 "Keywords")
Designations (see 1.1.2 "Symbols")
Information text
ULTRONIC™ 1 / ULTRONIC™ 2 TOUCHLESS AUTOMATIC HAND DRYERS | 3
ENGLISH
1.
GENERAL INFORMATION
SAFETY PRECAUTIONS
2.
Safety precautions
Please read and follow these instructions.
Failure to follow these instructions could
result in serious bodily injury or death.
!
There are no user-servicable parts. Service of
the unit must be performed by qualified service
technicians.
WARNING – TO REDUCE THE RISK OF FIRE, ELECTRIC
SHOCK, OR INJURY TO PERSONS, OBSERVE THE
FOLLOWING:
a) Use the unit only in the manner intended by the
manufacturer. If you have questions, contact the
manufacturer.
b) Before servicing or cleaning the unit, switch
power off at service panel and lock the service
disconnecting means to prevent power from
being switched on accidentally. When the service
disconnecting means cannot be locked, securely
fasten a prominent warning device, such as a tag, to
the service panel.
WARNING
! To reduce the risk of fire, or electric shock,
do not use this hand dryer with any solid state
speed control device.
DANGER Electrocution
Before proceeding with any installation,
adjustment, alteration, or service of this unit all
circuit breakers and disconnect switches servicing
the unit must be turned off. Failure to do so could
result in serious personal injury or death.
DANGER Electrocution: The unit must be
properly grounded. Failure to electrically
ground the product could result in serious personal
injury or death.
WARNING Injury
Where children or persons with limited
physical, sensory or mental capabilities are allowed
to control this appliance, ensure that this will only
happen under supervision or after appropriate instructions by a person responsible for their safety.
Children must be supervised to ensure that they
never play with the appliance.
WARNING Fire
Never operate this appliance ...
-if the minimum clearances to adjacent object surfaces are not maintained, for example to furniture,
net curtains, curtains, textiles or other flammable
materials (for minimum clearances, see specification/dimensions chapter).
- in rooms where the appliance is at risk from fire
or explosion as a result of chemicals, dust, gases or
vapors.
- in the direct proximity of pipes or containers that
carry or contain flammable or explosive materials.
- if work such as laying cables, grinding or sealing is
carried out in the installation room.
- if sprays, floor polish or similar products containing petroleum are used. Vent the room sufficiently
before using unit.
- if an appliance component is damaged, the appliance has fallen over or already had a fault.
Never remove the unit's cover unless the
electricity servicing the unit is turned off. Failure
to do so could result in serious personal injury or
death.
OPERATION
INSTRUCTIONS FOR THE END USER
3.
4.
Instructions for the end user
4.1
General use information
Register your product
You must register this product within 90
days of purchase on our website in order to
activate the standard warranty or to be eligible for
the extended warranty. Go to our web site at:
www.stiebel-eltron-usa.com and click on register
your product.
Before beginning the registration process, we
suggest that you gather the necessary information
which will be as follows:
Type, Example: Ultronic 1 S (from the black label that
is on the bottom of the unit)
Number listed after "Nr."
Place of Purchase
Purchase Date
First & Last Name
Email address
Physical Address
Phone Number
IF YOU HAVE ANY QUESTIONS CONCERNING THE
REGISTRATION PROCESS OR WARRANTY OPTIONS,
PLEASE CONTACT STIEBEL ELTRON USA DIRECTLY AT
(800)-582-8423.
Limited liability warranty:
Stiebel Eltron, Inc. is not liable for damages to the unit,
damage to personal property, bodily injury, or loss of
life due to the following conditions:
- Non-observance of these instructions
- Incorrect use
- Installation of the appliance by unqualified personnel
- Unauthorized modifications
- Technical modifications
- Use of unauthorized spare parts
In order to dry your hands most efficiently, please use
the following procedure:
Shake

off excess water over the wash basin
Place
 hands underneath the unit at a distance of
4˝ - 7˝
Rub
 your hands together as if you were washing
them
Your hands will be dry in approximately 15 seconds.
The Stiebel Eltron Ultronic series hand dryers are
equipped with an infrared sensor switch. This sensor
will activate the unit when hands are placed underneath
it. Approximately 7 seconds after the hands have been
removed, the unit will automatically shut off.
The sensor is the black rectangle located underneath the
unit between the air exit and air inlet grills. The sensor
switch will not work properly if it has been covered by
gum or dirt. If the sensor is obstructed, the hand dryer
will switch off automatically to prevent it from running
continuously.
4.2
User servicing instructions
The Ultronic hand dryer does not contain any
parts serviceable by the lay person. In case of
malfunction please contact a licensed electrician.
!
CAUTION Fire
Never spray cleaning spray into the air slot.
Ensure that no moisture can enter the appliance.
To clean the housing use a soft cloth with a mild
detergent if necessary. Never use any abrasive cleaners
since they will scratch the finish of the unit. Never spray
water or cleaning fluids directly on hand dryer. While
cleaning the unit, make sure the electric eye switch is
not covered.
ENGLISH
GENERAL INFORMATION
REGISTER YOUR PRODUCT
INSTALLATION
INSTALLATION INSTRUCTIONS FOR THE LICENSED INSTALLER
a) Installation work and electrical wiring must be
done by qualified person(s) in accordance with all
applicable codes and standards, including fire-rated
construction.
b) When cutting or drilling into wall or ceiling, do
not damage electrical wiring and other hidden utilities.
be splashed with water. Observe all minimum
clearance requirements. Failure to do so could result
in serious personal injury or death.
Do not install the hand dryer in DANGER ZONES 0, 1,
or 2 (see upper right diagram). Doing so may allow
the unit to be splashed with water which could
Before proceeding with any installation,
adjustment, alteration, or service of this unit all
circuit breakers and disconnect switches servicing
the unit must be turned off. Failure to do so could
24”
m)
(600 m
2
3
1
0
600
24” (
mm
118”
OBSERVE THE FOLLOWING:
WARNING Electrocution
Do not install unit where it can accidentally
)
WARNING Electrocution
The circuit should be equipped with a “ground fault
interrupter” where required by local, state or national
electrical codes.
The Ultronic hand dryer must have its own independent circuit using cable of the appropriate size
protected by a correctly rated circuit breaker. The
Ultronic 1 S/W units are designed for 110-120 Volt
electrical service and require a 15 amp circuit breaker and a #14 gauge copper wire. The Ultronic 2 S/W
units are designed for 220-240 V or 208 V electrical
service and require a 15 amp circuit breaker and a
#14 gauge copper wire.
D0000020798
12” (PP)
´(127 mm)
5.1” (130 mm)
0 DANGER ZONE: do not install unit in bathtubs
showers, or wash basins.
1 DANGER ZONE: do not install directly above bathtubs
or showers.
2 DANGER ZONE: do not install within 24˝ of bathtubs
or showers
3 SAFE AREA: unit must be installed in this area,
outside of DANGER ZONES 2, 1 and 0.
1.6” (40 mm)
All electrical work must comply with national
and applicable state and local electrical codes.
26_07_31_0167
Do not install unit where it can accidentally
be splashed with water, failure to do so could result
in serious personal injury or death.
(3000 mm)
WARNING: TO REDUCE THE RISK OF FIRE,
ELECTRIC SHOCK OR INJURY TO PERSONS,
Minimum clearances
89”
!
6.
(2250 mm)
5. Installation instructions for the
licensed installer
Before

mounting the unit to the wall, ensure
all minimum distances are met for safety and
performance considerations.
The
 unit must be installed at least 5˝ from
perpendicular walls.
The
 unit must be installed at least 12˝ above
countertops to avoid splashing the unit.
Ensure

the air outlet is not obstructed
Mounting the unit
7.1
Recommended mounting heights
Age
Age
lone für M ont a
26_07_32_0025
7.
ENGLISH
INSTALLATION
MOUNTING THE UNIT
Height
54˝ (1350 mm)
Adult woman
48˝ (1250 mm)
26_07_32_0047
Adult man
Rotate

the 2 lock screws one turn clockwise until
they come to a full stop.
Preschool /
kindergarten
3-5
32˝ (810 mm)
Elementary
school
6 - 10
36˝ (910 mm)
Remove

the housing by gently lifting upward from
the bottom. This will allow the hooks to disengage
from the attachment eyelets (see A, B, below). Once
the hooks have detached, pull the cover gently
forward to remove it.
2.
Middle
school
26_07_32_0046
3.
1.
10 - 13
44˝ (1120 mm)
B
A
High school
7.2
13 - 18
48˝ (1250 mm)
Wall mounting
26_07_32_0041
Transfer

the four mounting points to the wall
by using the enclosed drilling template and drill
mounting holes (see drawing, upper right).
A) Hooks
B) Attachment eyelets
INSTALLATION
ELECTRICAL CONNECTIONS
8.
Put
 the housing back onto the front of the unit.
Lift
 upward to reengage the hooks into the
attachment eyelets.
Press
 the housing down gently so it locks in place.
Electrical connections
2.
1
1.
26_07_32_0042
3.
26_07_32_0045
Turn
 the two screws a full turn counterclockwise to
stop.
85_07_32_0002
26_07_32_0043
1 Wiring block
Install

a 1/2˝ electrical connector in the back part of
housing in the hole located below the wiring block
(1, above).
Feed
 wires through connector; tighten clamp down
on wire.
The
 “live” wires must be connected to the slots
on the terminal marked N/L and L. The ground
wire must be connected to the slot on the terminal
marked with the ground symbol.
INSTALLATION
DIMENSIONS
0.2Ý (3 mm)
D0000020795
9.21Ý (234 mm)
2.5Ý (63 mm)
11.38Ý (289 mm)
b01
3.86Ý (98 mm)
0.16Ý (184 mm)
6.34Ý (161 mm)
10.2Ý (257 mm)
ENGLISH
Dimensions
3.2Ý (81 mm)
9.
0.67Ý (17 mm)
7.56Ý (192 mm)
10. Technical data
Model No.
Item no.
Electrical Data
Phase
Voltage
Wattage
Amperage
Minimum required
circuit breaker size
Min. required wire size
Dimensions
Height
Width
Depth
Weight
Weight
Construction
Color
Housing
Degree of protection (IP)
Safety class system
Other
Sound level
Air speed
Air volume
Drying time
Ultronic™ 1 S
231584
Ultronic™ 1 W
231585
Ultronic™ 2 S
231586
Ultronic™ 2 W
231587
single
120 V
985 W
8.5 A
single
120 V
985 W
8.5 A
single
208 V
775 W
3.85 A
single
208 V
775 W
3.85 A
Alpine white
Stainless steel
240 V
1000 W
4.3 A
240 V
1000 W
4.3 A
15 A
#14 AWG copper
11.4˝ / 289 mm
10.1˝ / 257 mm
9.2˝ / 234 mm
9.7 lb. / 4.4 kg
Stainless steel
aluminum
IP 23
I
Alpine white
82 dB(A)
210 mph / 94 m/s
170.7 CFM / 190 m³/h
15 seconds
WARRANTY | ENVIRONMENT AND RECYCLING
11. Warranty
RESIDENTIAL & COMMERCIAL WARRANTY: STIEBEL ELTRON WARRANTS TO THE ORIGINAL OWNER THAT THE ULTRONIC SERIES
TOUCHLESS AUTOMATIC HAND DRYER WILL BE FREE FROM DEFECTS IN WORKMANSHIP AND MATERIALS FOR A PERIOD OF THREE
(3) YEARS FROM THE DATE OF PURCHASE. SHOULD THE PART(S) PROVE TO BE DEFECTIVE UNDER NORMAL USE DURING THIS
PERIOD, STIEBEL ELTRON, INC. WILL BE RESPONSIBLE FOR REPLACEMENT OF THE DETECTIVE PART(S) ONLY. STIEBEL ELTRON,
INC. IS NOT RESPONSIBLE FOR LABOR CHARGES TO REMOVE AND/OR REPLACE THE DEFECTIVE PART(S), OR ANY INCIDENTIAL OR
CONSEQUENTIAL EXPENSES.
SHOULD THE OWNER WISH TO RETURN THE HAND DRYER FOR REPAIR, THE OWNER MUST FIRST SECURE WRITTEN AUTHORIZATION
FROM STIEBEL ELTRON, INC. THE OWNER SHALL BE REQUIRED TO SHOW PROOF OF PURCHASE DATE, AND TO PAY ALL TRANSPORTATION COSTS TO RETURN THE DEFECTIVE PART(S) OR HAND DRYER FOR REPAIR OR REPLACEMENT. WARRANTY IS VOID IF HAND
DRYER HAS BEEN INSTALLED OR USED IMPROPERLY OR IF DESIGN HAS BEEN ALTERED IN ANY WAY.
STIEBEL ELTRON, INC.
17 West Street
West Hatfield, MA 01088, USA
PHONE: 800-582-8423 or 413-247-3380
FAX:
413-247-3369
E-Mail
[email protected]
12. Environment and recycling
Please help us protect the environment. Dispose of the
appliance and its packaging in accordance with national
regulations.
STIEBEL ELTRON, INC.
17 West Street
West Hatfield, MA 01088, USA
PHONE: 800-582-8423 or 413-247-3380
FAX:
413-247-3369
E-Mail
[email protected]
Deutschland
STIEBEL ELTRON GmbH & Co. KG
Dr.-Stiebel-Straße | 37603 Holzminden
Tel. 05531 702-0 | Fax 05531 702-480
[email protected]
www.stiebel-eltron.de
Verkauf
Kundendienst
Tel. 0180 3 700705* | Fax 0180 3 702015* | [email protected]
Tel. 0180 3 702020* | Fax 0180 3 702025* | [email protected]
Tel. 05531 702-90015
Ersatzteilverkauf Tel. 0180 3 702030* | Fax 0180 3 702035* | [email protected]
Tel. 05531 702-90050
Vertriebszentren Tel. 0180 3 702010* | Fax 0180 3 702004*
* 0,09 €/min bei Anrufen aus dem deutschen Festnetz. Maximal 0,42 €/min bei Anrufen aus Mobilfunknetzen.
4<AMHCMN=jg f g>
Hungary
STIEBEL ELTRON Kft.
Pacsirtamező u. 41 | 1036 Budapest
Tel. 01 250-6055 | Fax 01 368-8097
[email protected]
www.stiebel-eltron.hu
Japan
NIHON STIEBEL Co. Ltd.
Kowa Kawasaki Nishiguchi Building 8F
66-2 Horikawa-Cho
Saiwai-Ku | 212-0013 Kawasaki
Tel. 044 540-3200 | Fax 044 540-3210
[email protected]
www.nihonstiebel.co.jp
Netherlands
STIEBEL ELTRON Nederland B.V.
Daviottenweg 36
5222 BH 's-Hertogenbosch
Tel. 073 623-0000 | Fax 073 623-1141
[email protected]
www.stiebel-eltron.nl
Poland
STIEBEL ELTRON Polska Sp. z o.o.
ul. Działkowa 2 | 02-234 Warszawa
Tel. 022 60920-30 | Fax 022 60920-29
[email protected]
www.stiebel-eltron.pl
Russia
STIEBEL ELTRON LLC RUSSIA
Urzhumskaya street 4,
building 2 | 129343 Moscow
Tel. 0495 7753889 | Fax 0495 7753887
[email protected]
www.stiebel-eltron.ru
Slovakia
TATRAMAT - ohrievače vody, s.r.o.
Hlavná 1 | 058 01 Poprad
Tel. 052 7127-125 | Fax 052 7127-148
[email protected]
www.stiebel-eltron.sk
Switzerland
STIEBEL ELTRON AG
Netzibodenstr. 23 c | 4133 Pratteln
Tel. 061 81693-33 | Fax 061 81693-44
[email protected]
www.stiebel-eltron.ch
Thailand
STIEBEL ELTRON Asia Ltd.
469 Moo 2 Tambol Klong-Jik
Amphur Bangpa-In | 13160 Ayutthaya
Tel. 035 220088 | Fax 035 221188
[email protected]
www.stiebeleltronasia.com
United Kingdom and Ireland
STIEBEL ELTRON UK Ltd.
Unit 12 Stadium Court
Stadium Road | CH62 3RP Bromborough
Tel. 0151 346-2300 | Fax 0151 334-2913
[email protected]
www.stiebel-eltron.co.uk
United States of America
STIEBEL ELTRON, Inc.
17 West Street | 01088 West Hatfield MA
Tel. 0413 247-3380 | Fax 0413 247-3369
[email protected]
Irrtum und technische Änderungen vorbehalten! | Subject to errors and technical changes! | Sous réserve
d‘erreurs et de modifications techniques! | Onder voorbehoud van vergissingen en technische wijzigingen! |
Salvo error o modificación técnica! | Excepto erro ou alteração técnica | Zastrzeżone zmiany techniczne i
ewentualne błędy | Omyly a technické změny jsou vyhrazeny! | A muszaki változtatások és tévedések jogát
fenntartjuk! | Отсутствие ошибок не гарантируется. Возможны технические изменения. | Chyby a
technické zmeny sú vyhradené!
Stand 8729
A 296655-36595-8732
B 296654-36528-8730
Austria
STIEBEL ELTRON Ges.m.b.H.
Eferdinger Str. 73 | 4600 Wels
Tel. 07242 47367-0 | Fax 07242 47367-42
[email protected]
www.stiebel-eltron.at
Belgium
STIEBEL ELTRON bvba/sprl
't Hofveld 6 - D1 | 1702 Groot-Bijgaarden
Tel. 02 42322-22 | Fax 02 42322-12
[email protected]
www.stiebel-eltron.be
Czech Republic
STIEBEL ELTRON spol. s r.o.
K Hájům 946 | 155 00 Praha 5 - Stodůlky
Tel. 251116-111 | Fax 235512-122
[email protected]
www.stiebel-eltron.cz
Denmark
Pettinaroli A/S
Mandal Allé 21 | 5500 Middelfart
Tel. 06341 666-6 | Fax 06341 666-0
[email protected]
www.stiebel-eltron.dk
Finland
Insinööritoimisto Olli Andersson Oy
Kapinakuja 1 | 04600 Mäntsälä
Tel. 020 720-9988 | Fax 020 720-9989
[email protected]
www.stiebel-eltron.fi
France
STIEBEL ELTRON SAS
7-9, rue des Selliers
B.P 85107 | 57073 Metz-Cédex 3
Tel. 0387 7438-88 | Fax 0387 7468-26
[email protected]
www.stiebel-eltron.fr

Stiebel Eltron Ultronic Hand Dryer Installation

Transcription

Similar documents

Submittal Sheet: Ultronic

7614f grain-vac - Krueger Grain Vacs

Sigma bite brochure

1445 with LEDs Watertight multipurpose luminaire

Welcome to - Serviced Office

Administrative Headquarters of Soto Zen Buddhism Head Temples

KeScan Nuctech XT2100 Data Sheet

Download-Brochure