CVT FLUID Checking CVT Fluid FLUID LEVEL CHECK

CVT FLUID
CVT FLUID
Checking CVT Fluid
PFP:KLE50
A
UCS005XN
FLUID LEVEL CHECK
Fluid level should be checked with the fluid warmed up to 50 to 80°C (122 to 176°F).
1. Check for fluid leakage.
2. With the engine warmed up, drive the vehicle to warm up the
CVT fluid. When ambient temperature is 20°C (68°F), it takes
about 10 minutes for the CVT fluid to warm up to 50 to 80°C
(122 to 176°F).
3. Park the vehicle on a level surface and set the parking brake.
4. With engine at idle, while depressing brake pedal, move the
selector lever throughout the entire shift range and return it to
the “P” position.
B
CVT
D
E
SMA146B
5.
Press the tab on the CVT fluid level gauge to release the lock
and pull out the CVT fluid level gauge from the CVT fluid charging pipe.
F
G
H
SCIA1933E
6.
Wipe fluid off the CVT fluid level gauge. Then rotate the CVT
fluid level gauge 180° and re-insert it into the CVT charging pipe
as far as it will go.
CAUTION:
Always use lint free paper towels to wipe fluid off the CVT
fluid level gauge.
I
J
K
L
SCIA1931E
7.
M
Remove the CVT fluid level gauge and check that the fluid level
is within the specified range as shown. If the fluid level is at or
below the low side of the range, add the necessary specified
NISSAN CVT fluid through the CVT charging pipe.
Fluid grade:
Refer to MA-14, "MR20DE" .
CAUTION:
● Only use specified NISSAN CVT fluid.
● Do not overfill the CVT.
SCIA1932E
8.
Install the CVT fluid level gauge to the CVT fluid charging pipe until it locks.
CAUTION:
When CVT fluid level gauge is installed into the CVT fluid charging pipe, make sure that the CVT
fluid level gauge is securely locked in place.
Revision: December 2006
CVT-15
2007 Sentra
CVT FLUID
FLUID CONDITION CHECK
Fluid status
Conceivable cause
Required operation
Varnished (viscous
varnish state)
CVT fluid become
degraded due to
hugh temperatures.
Replace the CVT fluid and check the
CVT main unit and the vehicle for
malfunctions (wire harness, cooler
pipes, etc.)
Milky white or
cloudy
Water in the fluid
Replace the CVT fluid and check for
places where water is getting in.
Large amount of
metal powder mixed
in fluid
Unusual wear of
sliding parts within
CVT
Replace the CVT fluid and check for
improper operation of the CVT.
ATA0022D
Changing CVT Fluid
1.
2.
Remove drain plug, and drain CVT fluid from oil pan.
Install drain plug with new gasket to oil pan and tighten to the specified torque.
Drain plug:
3.
UCS006Y9
Refer to CVT-204, "COMPONENTS" .
CAUTION:
Do not reuse drain plug gasket.
Fill CVT fluid from CVT fluid charging pipe to the specified level.
Fluid grade and capacity:
Refer to MA-14, "MR20DE" .
CAUTION:
● Use only Genuine NISSAN CVT Fluid NS-2. Do not mix with other fluid.
● Using CVT fluid other than Genuine NISSAN CVT Fluid NS-2 will deteriorate in driveability and
CVT durability, and may damage the CVT, which is not covered by the warranty.
● When filling CVT fluid, take care not to scatter fluid on heat generating parts such as exhaust.
● Sufficiently shake the container of CVT fluid before using.
4. With the engine warmed up, drive the vehicle in an urban area. When ambient temperature is 20°C
(68°F), it takes about 10 minutes for the CVT fluid to warm up to 50 to 80°C (122 to 176°F).
5. Check CVT fluid level and condition. Refer to CVT-15, "Checking CVT Fluid" .
6. Repeat steps 1 through 5 if CVT fluid is contaminated.
CAUTION:
Delete CVT fluid deterioration date with CONSULT-III after changing CVT fluid.
Revision: December 2006
CVT-16
2007 Sentra
RECOMMENDED FLUIDS AND LUBRICANTS
RECOMMENDED FLUIDS AND LUBRICANTS
MR20DE
PFP:00000
ELS002A9
Capacity (Approximate)
Description
Recommended Fluids/Lubricants
Liter
US measure
Imp measure
55.0
14 1/2 gal
12 1/8 gal
With oil filter
change
3.8
4 qt
3 3/8 qt
Without oil filter change
3.6
3 7/8 qt
3 1/8 qt
Dry engine (engine overhaul)
4.4
4 5/8 qt
3 7/8 qt
Cooling system
(with reservoir at max level)
7.0
1 7/8 gal
1 1/2 gal
Genuine NISSAN Long Life Anti-freeze
Coolant or equivalent
Manual transaxle fluid (MTF)
2.0
4 1/4 pt
3 1/2 pt
ELF XT4447 M+ 75W-80 or API GL-4, Viscosity SAE 75W-80
CVT fluid
8.3
8 3/4 qt
7 1/4 qt
Fuel
Engine oil
Drain and refill
Brake and clutch fluid
—
—
—
Multi-purpose grease
—
—
—
Windshield washer fluid
Air conditioning system refrigerant
Air conditioning system oil
3.5
3 3/4 qt
3 1/8 qt
0.50 ± 0.05 kg
1.10 ± 0.11 lb
1.10 ± 0.11 lb
5.03 fl oz
5.3 fl oz
120 m
Unleaded gasoline with an octane rating of
at least 87 AKI (RON 91)
●
API Certification Mark *1
Genuine NISSAN CVT Fluid NS-2 *2
Genuine NISSAN Super Heavy Duty
Brake Fluid*3 or equivalent DOT 3 (US
FMVSS No. 116)
NLGI No. 2 (Lithium soap base)
Genuine NISSAN Windshield Washer
Concentrate Cleaner & Anti-Freeze or
equivalent
HFC-134a (R-134a) *4
NISSAN A/C System Lubricant Type S or
equivalent *4
*1: For further details, see “SAE Viscosity Number”.
*2: Using transaxle fluid other than Genuine NISSAN CVT Fluid NS-2 will damage the CVT, which is not covered by the NISSAN
new vehicle limited warranty.
*3: Available in mainland U.S.A. through your NISSAN dealer.
*4: For further details, see “Air conditioner specification label”.
QR25DE
ELS002DP
Capacity (Approximate)
Description
Recommended Fluids/Lubricants
Liter
US measure
Imp measure
55.0
14 1/2 gal
12 1/8 gal
With oil filter
change
4.9
5 1/8 qt
4 3/8 qt
Without oil filter
change
4.6
4 7/8 qt
4 qt
Dry engine (engine overhaul)
5.0
5 1/4 qt
4 3/8 qt
Cooling system
(with reservoir at max level)
7.6
2 gal
1 5/8 gal
Genuine NISSAN Long Life Anti-freeze /
Coolant or equivalent
Manual transaxle fluid (MTF)
2.0
4 1/4 pt
3 1/2 pt
ELF XT4447 M+ 75W-80 or API GL-4,
Viscosity SAE 75W-80
CVT fluid
8.3
8 3/4 qt
7 1/4 qt
Genuine NISSAN CVT Fluid NS-2 *2
Brake and clutch fluids
—
—
—
Genuine NISSAN Super Heavy Duty
Brake Fluid or equivalent, DOT 3 (US
FMVSS No. 116) *3
Multi-purpose grease
—
—
—
NLGI No. 2 (Lithium soap base)
Fuel
Engine oil
Drain and refill
Revision: December 2006
MA-14
Unleaded gasoline with an octane rating
of at least 87 AKI (RON 91)
●
API Certification Mark *1
2007 Sentra
RECOMMENDED FLUIDS AND LUBRICANTS
Capacity (Approximate)
Description
Windshield washer fluid
Air conditioning system refrigerant
Air conditioning system oil
Liter
US measure
Imp measure
3.5
3 3/4 qt
3 1/8 qt
0.50 ± 0.05 kg
1.10 ± 0.11 lb
1.10 ± 0.11 lb
5.03 fl oz
5.3 fl oz
120 m
Recommended Fluids/Lubricants
A
Genuine NISSAN Windshield Washer
Concentrate Cleaner & Anti-freeze or
equivalent
B
HFC-134a (R-134a) *4
NISSAN A/C System Lubricant Type S or
equivalent *4
*1: For further details, see “SAE Viscosity Number”.
*2: Using transaxle fluid other than Genuine NISSAN CVT Fluid NS-2 will damage the CVT, which is not covered by the NISSAN
new vehicle limited warranty.
*3: Available in mainland U.S.A. through your NISSAN dealer.
*4: For further details, see “Air conditioner specification label”.
C
D
E
F
G
H
I
J
K
MA
M
Revision: December 2006
MA-15
2007 Sentra
TRANSAXLE ASSEMBLY
TRANSAXLE ASSEMBLY
Removal and Installation (MR20DE)
PFP:32020
UCS006YQ
COMPONENTS
WCIA0674E
1.
CVT fluid level gauge
2.
CVT fluid charging pipe
3.
O-ring
4.
Hose clamp
7.
Water hose
5.
CVT water hose
6.
Water thermostat tube
8.
Transaxle assembly
9.
10.
CVT water hose
A.
Air breather hose
To engine coolant outlet
B.
To water pump
C.
Refer to CVT-205, "INSTALLATION" .
REMOVAL
1.
2.
3.
Remove the engine and transaxle as an assembly. Refer to EM-102, "Removal and Installation" .
Disconnect the electrical connectors from the following:
● Secondary speed sensor (1)
● Primary speed sensor (2)
● CVT unit connector (3)
● PNP switch (4)
Remove the harness from the CVT.
WCIA0673E
Revision: December 2006
CVT-204
2007 Sentra