CDX-C90 -- Service Manual

Transcription

CDX-C90
SERVICE MANUAL
US Model
E Model
Ver 1.1 2001. 08
SPECIFICATIONS
Model Name Using Similar Mechanism
CDX-C680/C780
CD Drive Mechanism Type
MG-363S-121
Optical Pick-up Name
KSS-520A
AUDIO POWER SPECIFICATIONS (US model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
19 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more than
1 % total harmonic distortion.
Other specifications
CD player section
System
AM
Tuning range
AM tuning interval:
9 kHz/10 kHz switchable
531 - 1,602 kHz
(at 9 kHz step)
530 - 1,710 kHz
(at 10 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.71 MHz/450 kHz
Sensitivity
30 dBµV
Compact disc digital audio
system
108 dB
5 - 20,000 Hz (±1 dB)
Below measurable limit
Signal-to-noise ratio
Frequency response
Wow and flutter
Laser Diode Properties
Material
GaAlAs
Wavelength
780 nm
Emission Duration
Continuous
Laser output power
Less than 44.6 µW*
* This output is the value measured at a distance of
200 mm from the objective lens surface on the Optical
Pick-up Block.
General
Outputs
Tuner section
FM
Tuning range
FM tuning interval:
50 kHz/200 kHz switchable
87.5 - 108.0 MHz
(at 50 kHz step)
87.5 - 107.9 MHz
(at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz
Usable sensitivity
8 dBf
Selectivity
75 dB at 400 kHz
50 dB at 200 kHz
Signal-to-noise ratio
65 dB (stereo),
68 dB (mono)
Harmonic distortion at 1 kHz
0.3% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
20 - 15,000 Hz (±0.5 dB)
Tone controls
Power requirements
Digital output
Line outputs (3)
Power antenna relay
control lead
Power amplifier control
lead
Telephone ATT control
lead
Illumination control lead
Bass ±8 dB at 100 Hz
Treble ±8 dB at 10 kHz
12 V DC car battery
(negative ground)
– Continued on next page –
FM/AM COMPACT DISC PLAYER
9-925-982-12
Sony Corporation
2001H0400-1
© 2001. 8
e Vehicle Company
Shinagawa Tec Service Manual Production Group
–1–
Dimensions
Mounting dimension
Mass
Supplied accessories
Approx. 178 × 50 × 184 mm
(7 1/8 × 2 × 7 1/4 in.)
(w/h/d)
Approx. 182 × 53 × 163 mm
(7 1/4 × 2 1/8 × 6 1/2 in.)
(w/h/d)
Approx. 1.6 kg (3 lb. 8 oz.)
Parts for installation and
connections (1 set)
Rotary remote RM-X90 (1)
Wireless remote RM-X9 (1)
Front panel case (1)
Design and specifications are subject to change without
notice.
SERVICE NOTE
NOTES ON CLEANING THE OBJECTIVE LENS
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
cotton swabs
objective lens
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
2-axis actuator
optical pick-up
2-axis cover
slide base
Apply CD lens cleaner B-4 (Part No.:J-2501-000-A) to cotton swabs
(narrow type) (Part No.:J-2501-023-A) to be lightly wet. Use a force
(about 5 g (0.18 oz)) to make the objective lens in contact with the
bottom lightly, and clean the lens by spirals as following below.
Replace the cotton swab and repeat this cleaning two or three times.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
surface of objective lens
NOTES ON PICK-UP FLEXIBLE BOARD
The pick-up flexible board in this set is secured to the optical pickup with an adhesive tape. Once the tape is removed, an adhering
force becomes weak, and it cannot be reused.
Therefore, if the optical pick-up is replaced, replace also the pickup flexible board with a new one.
Notes:
Do not force to push the objective lens. Otherwise, the plate spring
supporting the objective lens will be bent, causing a deteriorated
RF waveform.
Never touch anything other than the objective lens. Otherwise, a
significant deterioration occurs in the RF waveform.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
–2–
TABLE OF CONTENTS
1. GENERAL
3. ELECTRICAL ADJUSTMENTS
Initial settings .......................................................................... 4
Setting the clock ...................................................................... 5
Using the main panel controls ................................................. 6
Basic oprations ........................................................................ 7
Using the rotary remote ........................................................... 8
Using the wireless remote ....................................................... 9
Menu display/Lists ................................................................ 10
Listening to a CD/MD ........................................................... 10
Playing tracks repeatedly ....................................................... 11
Playing tracks in random order ............................................. 12
Creating a program ................................................................ 12
Labeling a CD ....................................................................... 14
Selecting specific tracks for playback ................................... 15
Locating a disc by name ........................................................ 16
Viewing CD TEXT information ............................................ 17
Customizing the CD sound .................................................... 18
Listening to radio ................................................................... 18
Presetting radio stations ......................................................... 19
Specifying monaural/stereo mode ......................................... 20
Receiving only the strongest signals ..................................... 21
Labeling radio stations .......................................................... 22
Selecting a station by name ................................................... 23
Adjusting the sound characteristics ....................................... 23
Setting the set up menu ......................................................... 24
Setting the display menu ....................................................... 25
Setting the function menu ...................................................... 26
Selecting a surround menu .................................................... 26
Storing a surround effect for CDs ......................................... 27
Selecting the listening position .............................................. 28
Adjusting the cut-off frequency of the subwoofer(s) ............ 29
Adjusting the turn-over frequency of the bass and treble ...... 30
Additional information .......................................................... 31
Connections ........................................................................... 33
CD Section ............................................................................ 44
Tuner Section ......................................................................... 44
4. DIAGRAMS
4-1. IC Pin Descriptions ........................................................... 47
4-2. Block Diagram –CD Section– ........................................... 57
4-3. Block Diagram –Main Section– ........................................ 59
4-4. Block Diagram –Display Section– .................................... 61
4-5. Circuit Boards Location .................................................... 63
4-6. Printed Wiring Boards –CD Mechanism Section– ............ 63
4-7. Schematic Diagram –CD Mechanism Section– ................ 67
4-8. Schematic Diagram –Audio Section– ............................... 72
4-9. Printed Wiring Board –Audio Section– ............................ 75
4-10. Schematic Diagram –Main Section (1/2)– ........................ 77
4-11. Schematic Diagram –Main Section (2/2)– ........................ 82
4-12. Printed Wiring Boards –Main Section– ............................ 87
5. EXPLODED VIEWS
5-1.
5-2.
5-3.
5-4.
5-5.
5-6.
Case Section ...................................................................... 96
Front Panel Section ........................................................... 97
Chassis Section ................................................................. 98
CD Mechanism Section (1) ............................................... 99
CD Mechanism Section (2) ............................................. 100
CD Mechanism Section (3) ............................................. 101
6. ELECTRICAL PARTS LIST ...................................... 102
2. DISASSEMBLY
2-1. Cover (Upper) ................................................................... 35
2-2. Front Panel Assy ............................................................... 35
2-3. Cords ................................................................................. 36
2-4. Rear Panel ......................................................................... 36
2-5. MD Assy ........................................................................... 37
2-6. Audio Board ...................................................................... 37
2-7. Bracket (MD) .................................................................... 38
2-8. Motor Block ...................................................................... 38
2-9. Base Panel Assy ................................................................ 39
2-10. Sub Panel Assy .................................................................. 39
2-11. Chassis (Front) Assy ......................................................... 40
2-12. Main Board ....................................................................... 40
2-13. Chassis (T) Sub Assy ........................................................ 41
2-14. Lever Assy ......................................................................... 41
2-15. Servo Board ....................................................................... 42
2-16. Roller Assy ........................................................................ 42
2-17. Chassis (OP) (O/S) Assy ................................................... 43
2-18. Optical Pick-up Block ....................................................... 43
–3–
SECTION 1
GENERAL
–4–
This section is extracted
from instruction manual.
–5–
–6–
–7–
–8–
–9–
– 10 –
– 11 –
– 12 –
– 13 –
– 14 –
– 15 –
– 16 –
– 17 –
– 18 –
– 19 –
– 20 –
– 21 –
– 22 –
– 23 –
– 24 –
– 25 –
– 26 –
– 27 –
– 28 –
– 29 –
– 30 –
– 31 –
– 32 –
– 33 –
– 34 –
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. COVER (UPPER)
5
1 PTT 2.6x4
4
7 cover (upper)
6 claws
3
2
2-2. FRONT PANEL ASSY
3 front panel assy
2
1 Push the button (release).
– 35 –
2-3. CORDS
8 cord (with connector)
(INVERTER)
(EL transformer unit)
7 PTT 2.6x4
4 cord (with connector) (RCA)
(BUS AUDIO IN, SUB OUT)
3 PTT 2.6x4
5 PTT 2.6x4
6 power cord
1 PTT 2.6x4
2 cord (with connector) (RCA)
(FRONT LINE OUT, REAR LINE OUT)
2-4. REAR PANEL
5 PTT 2.6x4
3 PTT 2.6x4
6 rear panel
1 PTT 2.6x4
2 PTT 2.6x4
4 PTT 2.6x4
– 36 –
2-5. MD ASSY
7 MD assy
5 CN101
3 PTT 2.6x4
1 Slide the base panel
in the direction of the
arrow.
6 CN3
4 CN1
2 PTT 2.6x4
2-6. AUDIO BOARD
2 BVTT 2x4
3 AUDIO board
1 BVTT 2x4
– 37 –
2-7. BRACKET (MD)
3 bracket (MD)
2 PTT 2.6x4
5 COVER (MD)
1 PTT 2.6x4
4 PTT 2.6x4
2-8. MOTOR BLOCK
3 PTT 2.6x4
6 motor block
5shaft
2 PTT 2.6x4
1 CN600
4 P 2X2.5
– 38 –
2-9. BASE PANEL ASSY
FLEXIBLE board
claws
1 step screw
(M1.7)
3
5 CN300
2 step screw (M1.7)
6 base panel assy
4
2-10. SUB PANEL ASSY
1 B 2x4
3 PTT 2.6x4
2 B 2x4
4 sub panel assy
– 39 –
2-11. CHASSIS (FRONT) ASSY
1 ground point screw
2 ground point
screws
8 shaft (pinion) assy
3 P 2x2.5
4 bracket
(shaft pinion)
5 B 2.6x3
9 lever (L) assy
6 B 2.6x3
7 chassis (front) assy
0 lever (R) assy
2-12. MAIN BOARD
3 MAIN board
2 cord (with connector) (ANT)
1 PTT 2.6x6
4 sheet (insulating 90)
power cord
– 40 –
2-13. CHASSIS (T) SUB ASSY
1 P 2x3
2 P 2x3
3 chassis (T) sub assy
2-14. LEVER ASSY
5 guide (disc)
6 lever (R) assy
3 tension spring (LR)
7 lever (L) assy
1 PS 2x4
2 DISC IN SW board
4 claws
– 41 –
2-15. SERVO BOARD
2 PS 2x5
1 PS 2x5
3 heat sink
7 CN2
0 SERVO board
6 PS 2x4
4 CN4
5 CN5
8 P 2x3
9 loading motor assy
2-16. ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
washer
arm
washer
washers arm
Fig. 1
3 roller assy
4 PS 2x3
2 arm (roller)
5 LOAD SW board
1 tension spring (RA)
– 42 –
2-17. CHASSIS (OP) (O/S) ASSY
6 chassis (OP) (O/S) assy
8 compression spring (FL)
1 tension spring (angle)
7 compression spring (FL)
4 Fit lever (D) in the
direction of the arrow.
5 Turn loading ring in the
direction of the arrow.
3 damper (T)
2 damper (T)
2-18. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy
3 optical pick-up block
– 43 –
SECTION 3
ELECTRICAL ADJUSTMENTS
FM Auto Scan/Stop Level Adjustment
Setting :
SOURCE button : FM
CD SECTION
CD section adjustments are done automatically in this set.
TUNER SECTION
0 dB = 1 µV
FM RF signal
generator
Cautions during repair
When the tuner unit is defective, replace it by a new one
because its internal block is difficult to repair.
antenna
terminal
0.01 µF
TEST MODE
set
This set have the test mode function. In the test mode, FM Auto
Scan/Stop Level and AM Auto Scan/Stop Level adjustments can be
performed easier than it in ordinary procedure.
<Set the Test Mode>
1. Set the “OFF” mode.
2. Push the preset 4 button.
4. Press the preset 1 button for more than two seconds.
5. Then the display indicates all lights, the test mode is set.
Carrier frequency
Output level
Mode
Modulation
: 97.9 MHz
: 22 dB (12.6 µV)
: mono
: 1 kHz, 22.5 kHz deviation (30%)
Procedure :
1. Set to the test mode.
2. Push the SOURCE button and set to FM.
Display
<Release the Test Mode>
1. Push the OFF button.
D
Note on Adjustment
The adjustments of tuner section, should be performed according
to the following sequence.
1. FM Auto Scan/Stop Level Adjustment
2. FM Stereo Separation Adjustment (WIDE)
3. FM Stereo Separation Adjustment (NARROW)
4. AM Auto Scan/Stop Level Adjustment
EL
Display
D
EL
4. Adjust with the volume RV2 on TU701 so that the “FM”
indication turns to “FM0” indication on the display window.
But, in case of already indicated “FM0”, turn the RV2 so that
put out light “0” indication and adjustment.
Display
D
EL
Adjustment Location : See page 46.
– 44 –
Ver 1.1
FM Stereo Separation Adjustment (WIDE)
Setting :
SOURCE button : FM
FM RF signal
generator
0.01 µF
FM Stereo Separation Adjustment (NARROW)
Setting :
SOURCE button : FM
FM RF signal
generator
level meter
antenna
terminal
10 k Ω
0.01 µF
set
Carrier frequency
Output level
Mode
Modulation
Procedure :
2. Push the SHIFT button.
3. Push the 4 button three times.
4. Push the 5 button once and set to WIDE mode.
Level meter
Level meter
connection
reading (dB)
L-CH
L-CH
A
R-CH
L-CH
R-CH
L-CH
signal generator
output channel
10 k Ω
set
: 97.9 MHz
LINE OUT REAR
: 70 dB (3.2 mV)
: stereo
: main : 1 kHz, 33.75 kHz deviation (45%)
sub : 1 kHz, 33.75 kHz deviation (45%)
19 kHz pilot : 7.5 kHz deviation (10%)
FM stereo
level meter
antenna
terminal
Carrier frequency
Output level
Mode
Modulation
: 97.9 MHz
LINE OUT REAR
: 70 dB (3.2 mV)
: stereo
: main : 1 kHz, 33.75 kHz deviation (45%)
sub : 1 kHz, 33.75 kHz deviation (45%)
19 kHz pilot : 7.5 kHz deviation (10%)
Procedure :
2. Push the SHIFT button.
3. Push the 4 button three times.
4. Push the 5 button twice and set to NARROW mode.
FM stereo
Level meter
Level meter
connection
reading (dB)
L-CH
L-CH
A
B
Adjust RV3 on TU701
for minimum reading.
R-CH
L-CH
B
Adjust RV4 on TU701
R-CH
C
R-CH
R-CH
C
R-CH
D
Adjust RV3 on TU701
L-CH
R-CH
D
Adjust RV4 on TU701
signal generator
output channel
L-CH stereo separation : A – B
R-CH stereo separation : C – D
The separations of both channels should be equal.
L-CH stereo separation : A – B
R-CH stereo separation : C – D
The separations of both channels should be equal.
Specification : Separation more than 24 dB
Specification : Separation more than 18 dB
– 45 –
AM Auto Scan/Stop Level Adjustment
Setting :
SOURCE n MODE button : AM
Adjustment Location : tuner unit (TU701)
–set upper view–
30 Ω 15 pF
65 pF
AM RF signal
generator
AM dummy
antenna (50 Ω)
TU701
set
Carrier frequency : 1000 kHz
30% amplitude
modulation by
1 kHz signal
output level
: 33 dB (44.7 µV)
RV1
AM AUTO SCAN/
STOP LEVEL ADJ
antenna
terminal
RV2
FM AUTO SCAN/
STOP LEVEL ADJ
RV3
FM STEREO
SEPARATION ADJ
(WIDE)
Procedure :
1. Set to the test mode. (See page 44.)
2. Push the SOURCE button.
3. Push the MODE button and set to AM.
Display
RV4
FM STEREO
SEPARATION ADJ
(NARROW)
D
EL
Display
D
EL
5. Adjust with the volume RV1 on TU701 so that the “AM”
indication turns to “AM0” indication on the display window.
But, in case of already indicated “AM0”, turn the RV1 so that
put out light “0” indication and adjustment.
Display
D
EL
Adjustment Location : tuner unit (TU701)
– 46 –
SECTION 4
DIAGRAMS
4-1. IC PIN DESCRIPTIONS
• IC5 CXP84640-011Q (CD SYSTEM CONTROL)
Pin No.
1–5
Pin Name
NCO
I/O
—
Pin Description
6
7
FP OPEN
FP CLOSE
I
O
Front panel open detection input
Front panel close control output
8
9
LINKOFF
DRV OE
I
O
Bus interface link input (Not used in this set.)
Focus/tracking coil/sled motor control output
10
11 – 13
D SW
NCO
I
—
Down switch input (SW4)
Not used in this set.
14
15
LM EJ
LM LOD
O
O
Loading motor control output
Loading motor control output
16
17
EMPH O
CDMON
O
O
De-emphasis ON/OFF control output
CD mechanism deck power control output
18
19
CD ON
A MUT
O
O
CD power control output
System attenuate control output
20
21
LD ON
CD RST
O
O
Lazer power ON/OFF control output
CD system reset output
22 – 24
25
—
PH3
—
I
26
27
TSTIN0
TSTIN1
I
I
28
29
TST CLV
NCO
I
—
30
31
32
RESET
X IN
X OUT
I
I
O
System reset input (“L” = Reset)
X’tal oscillator input of system clock. (10 MHz)
X’tal oscillator output of system clock. (10 MHz)
33
34
GND
XT OUT
—
O
Analog GND
35
36
XT IN
AVSS
I
—
A/D converter GND
37
38
AVREF
TEP L
I
I
39
40
TEP H
NCO
I
—
41
42
PH2
SCLK
I
O
CD-TEXT data read clock output
43
44
ESPXQOK
ESPSDT
O
I
XQOK signal output to DRAM controller.
Serial data input from DRAM controller.
45
46
GRSRST
GRSCOR
O
I
Reaet signal output to DRAM controller.
Sub-cord sync input from DRAM controller.
47
48
CD XLAT
TX CLK
O
O
CD signal process serial latch output
EEPROM serial clock output
49
50
TX DATA
UNISO
O
O
EEPROM serial data output
51
52
BUS CLK
BUS SI
I/O
I
53
54
BUS SO
F OK
O
I
Bus system serial interface output
Focus OK signal input
55
56
GFS
SCOR
I
O
GFS signal detection input
Sub-cord sync output
57
58
SENS
—
I
I
SENS signal input
Fixed at “H” in this set.
59
CD CKO
O
CD signal process serial clock output
A/D converter reference voltage input
Bus system serial clock input/output
Bus system serial interface input
– 47 –
Pin No.
Pin Name
I/O
Pin Description
60
BU.IN
I
Back-up power detection input
61
62
BUSON
IN SW
I
I
Bus on control input
Disc in switch input (SW1)
63
64
SELF SW
TX CE
I
O
Self switch input (SW2)
EEPROM chip enable output
65
66
SCK2
SI2
O
I
Sub Q read clock output
Sub Q 80 bit, PCM peak and level data 16 bit input
67
68
CD DATA
ESPXWRE
O
O
CD signal process serial data output
Write signal output to DRAM controller.
69
70
ESPXRDE
ESPXLT
O
O
Read signal output to DRAM controller.
Serial data latch output to DRAM controller.
71
72
ESPXSOE
VDD
O
—
XSOE signal output to DRAM controller.
Power supply
73
74
HIN
TEXT.ON/OFF
I
I
75
76
PH1
FBTBSEL
I
I
77
78 – 80
CDOSEL
—
I
—
– 48 –
• IC501 CXD2548R (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR)
Pin No.
Pin Name
I/O
Pin Description
1
SYSM
I
System mute input (Not used.)
2
3
RMUT1
LMUT2
O
O
R-ch, “0” detection output. (“H” : ON, “L” : OFF) (Not used.)
L-ch, “0” detection output. (“H” : ON, “L” : OFF) (Not used.)
4
5
CKOUT
VDD0
O
—
Master clock frequency division output (Not used.)
Digital power supply
6
7
SBSO
EXCK
O
I
Serial output of sub-P to W.
Clock input for SBSO read output.
8
9
SQCK
SQSO
I
O
Clock input for SQSO read output.
SubQ 80 bit, PCM peak and level data 16 bit output.
10
11
SENS
SCLK
O
I
SENS output. Output to CPU.
Clock input for SENS real data read.
12
13
DATA
XLAT
I
I
Serial data input from CPU.
Latch input from CPU. Latch serial data at the falling edge.
14
15
CLOK
XRST
I
I
Serial data transfer clock input from CPU.
System reset (“L” : Reset)
16
17
ACDT
PWM1
O
I
Not used.
External control input of spindle motor.
18
19
XLON
SPOA
O
I
Microcomputer extension interface (Output) (Not used.)
Microcomputer extension interface (Input A) (Not used.)
20
21
WFCK
GTOP
O
O
WFCK (Write Flame Clock) output
GTOP output
22
23
XUGF
XPCK
O
O
XUGF output (Not used.)
XPLCK output (Not used.)
24
25
GFS
RFCK
O
O
GFS output
RFCK output
26
27
C2PO
XROF
O
O
C2PO output (Not used.)
XROF output
28
29
SCOR
MNT0
O
O
“H” output at either detection, sub code sync S0 or S1.
MNT0 output (Not used.)
30
31
MNT1
MNT3
O
O
32
33
VSS1
DOUT
—
O
Digital GND
Digital-Out output
34
35
ATSK
MIRR
I
O
For anti-shock.
Mirror signal output (Not used.)
36
37
DFCT
FOK
O
O
Diffect signal output (Not used.)
Focus OK signal output
38
39
VDD1
VPCO1
—
O
Charge pump output for wideband EFM PLL.
40
41
VPCO2
VCK.I
O
I
VCO2 charge pump output for wideband EFM PLL.
VCO2 oscillator input for wideband EFM PLL.
42
43
V16M
VCTL
O
I
VCO2 oscillator output for wideband EFM PLL.
VCO2 control input for wideband EFM PLL.
44
45
PCO
FILO
O
O
Charge pump output for master PLL.
Filter output for master PLL (Slave = digital PLL).
46
47
FILI
AVSS4
I
—
Filter input for master PLL.
Analog GND
48
49
CLTV
AVDD4
I
—
VCO control voltage input for master.
Analog power supply
50
51
RFAC
BIAS
I
I
EFM signal input
Asymmetry circuit constant current input
52
ASY.I
I
Asymmetry comparate voltage input
– 49 –
Pin No.
53
Pin Name
ASY.O
I/O
O
Pin Description
EFM full-swing output (“L” : VSS, “H” : VDD)
54
55
VC
FE
I
I
Center voltage input
Focus error signal input
56
57
SE
TE
I
I
Sled error signal input
Tracking error signal input
58
59
CE
RFDC
I
I
Center error signal input
RF signal input
60
61
RFC
ADIO
I
O
Condenser connection pin for LPF time constant of RF signal.
OP amplifier output (Not used.)
62
63
AVSS3
IGEN
—
I
Analog GND
Current source reference resistor connection for OP amplifier.
64
65, 66
AVDD3
TES2, 3
—
I
Analog power supply
TEST pin (Fixed at “L”.)
67
68
VSS2
TEST
—
I
Digital GND
TEST pin (Fixed at “L”.)
69
70
SFDR
SRDR
O
O
Sled drive output
Sled drive output
71
72
TFDR
TRDR
O
O
Tracking drive output
Tracking drive output
73
74
FFDR
FRDR
O
O
Focus drive output
Focus drive output
75
76
VDD2
COUT
—
O
Track number count signal output (Not used.)
77
78
79
LOCK
MDS
MDP
O
O
O
Not used.
Servo control output of spindle motor. (Not used.)
Servo control output of spindle motor.
80
81
SSTP
FSTO
I
O
Disc most inner track detection signal input
2/3 frequency division output of pins 103 and 104.
82
83
FSTI
XTSL
I
I
Reference clock input for digital servo.
X’tal select input (“L” : 16.9344 MHz)
84
85
C4M
WDCK
O
O
4.2336 MHz output
D/A interface. Word clock f = 2Fs
86
87
VDD3
LRCK
—
O
D/A interface. LR clock f = Fs
88
89
LRCKI
PCMD
I
O
LR clock input to DAC. (48 bit slot) (Not used.)
D/A interface. Serial data (2’s COMP, MSB first)
90
91
PCMDI
BCK
I
O
Audio data input to DAC. (48 bit slot) (Not used.)
D/A interface. Bit clock
92
93
BCKI
EMPH
I
O
Bit clock input to DAC. (48 bit slot) (Not used.)
Not used.
94
95
EMPHI
VSS3
I
—
De-emphasis ON/OFF of DAC. (“H” : ON, “L” : OFF) (Not used.)
Digital GND
96
97
AVSS1
AVDD1
—
—
L-ch, Analog GND.
L-ch, Analog power supply.
98
99
AOUT1
AIN1
O
I
L-ch, Analog output. (Not used.)
L-ch, OP amplifier input. (Not used.)
100
101
LOUT1
AVSS1
O
—
L-ch, LINE output. (Not used.)
L-ch, Analog GND.
102
103
XVDD
XTAI
—
I
Analog power supply for master clock.
X’tal oscillator input of master clock (16.9344 MHz).
104
XTAO
O
X’tal oscillator output of master clock. (Not used.)
105
XVSS
—
Analog GND for master clock.
106
AVSS2
—
R-ch, Analog GND.
– 50 –
Pin No.
107
Pin Name
ROUT2
I/O
O
Pin Description
108
109
AIN2
AOUT2
I
O
R-ch, OP amplifier input. (Not used.)
R-ch, Analog output. (Not used.)
110
111
AVDD2
AVSS2
—
—
R-ch, Analog power supply.
R-ch, Analog GND.
112
VSS0
—
Digital GND
R-ch, LINE output. (Not used.)
– 51 –
• IC300 MB90F574PFV-G-139-BND (SYSTEM CONTROL)
Pin No.
1
Pin Name
TIR WR
I/O
O
Pin Description
TIR IC data write output (Not used in this set.)
2
3
TIR RD
TIR CE
O
O
TIR IC data read output (Not used in this set.)
TIR IC data chip enable output (Not used in this set.)
4
5
TIR CE
TIR BUSY
O
I
XTIR IC data chip enable output (Not used in this set.)
TIR IC busy input (Not used in this set.)
6
7
TIR PDOWN
DIVER
O
O
TIR IC power down output (Not used in this set.)
FM diversity ON/OFF output (Not used in this set.)
8
9
VCC
AF SEEK
—
O
Power supply pin (+5 V)
AF SEEK output (Not used in this set.)
10
11
WIDE
CAUTION
O
I
WIDE/NARROW select output
Caution alarm setting (Fixed at “H” in this set.)
12
13
NOSE SW
COLOR
I
O
Nose detection input
Color control output (“H”:green, “L”:amber)
14
15
BUSON
BEEP
O
O
Bus ON control output
BEEP output
16
17
TIR RES
DF LAT
O
O
TIR IC reset (Power down) output (Not used in this set.)
Digital filter latch output
18
19
DF SO
DF CKO
O
O
Digital filter serial data output
Digital filter clock output
20
21
UNISI
UNISO
I
O
Serial data input (for UNI LINK)
Serial data output (for UNI LINK)
22
23
UNICK
NCO
O
—
Serial clock output (for UNI LINK)
Not used.
24
25
26
SIRCS
PLLSI
PLLSO
I
I
O
Remote commander input
PLL data input
PLL data output
27
28
PLLCKO
PLL CE
O
O
PLL clock output
PLL chip enable output
29
30
P MOT+
P MOT–
O
O
Front panel motor control (+) output
Front panel motor control (–) output
31
32
I DET
POS0
I
I
Panel motor lock detection input
Position detection input 0 (Open end)
33
34
GND
C
—
—
35
36
POS1
POS2
I
I
Position detection input 1 (Close end)
Position detection input 2 (10 DEG.)
37
38
POS3
DVCC
I
—
Position detection input 3 (20 DEG.)
D/A converter VREF input
39
40
DVSS
MOTREF
—
O
GND of D/A converter.
Motor reference voltage output
41
42
LCDANG
AVCC
O
—
LCD view angle adjustment analog output
Analog power supply pin (+5 V)
43
44
AVRH
AVRL
—
—
A/D converter VREF+ input
A/D converter VREF– input
45
46
AVSS
DSTSEL0
—
I
Analog GND
Destination select input 0 (Fixed at “H” in this set.)
47
48
H TEMP
L TEMP
I
I
High templature detection analog input (Fixed at “H” in this set.)
Low templature detection analog input (Fixed at “H” in this set.)
49
50
MPT
VSM
I
I
Tuner multi-pass input (Not used in this set.)
S-Meter voltage detection input
51
52, 53
RC IN0
KEYIN0, 1
I
I
Rotary commander input 0
Key input 0, 1
GND
Power stabilization capacitor pin
– 52 –
Pin No.
54
Pin Name
VCC
I/O
—
Pin Description
55
56
RAMBU
TESTIN
I
I
RAM reset detection input
Test mode setting detection input
57
58, 59
AD ON
RE IN0, 1
O
I
Power control output of A/D conversion.
Rotary encoder input 0, 1
60
61
BOOT
DIMMER
I
O
Compulsory boot mode input
Dimmer control output
62
63
TIR IND
GND
O
—
TIR indicator control output (Not used in this set.)
GND
64
65, 66
SYSRST
NCO
O
—
System reset output
Not used.
67
68
EEDATA
EECLK
I/O
O
EEPROM serial data input/output
EEPROM serial clock output
69
70
NCO
RDSSI
—
I
Not used.
RDS serial clock input (Not used in this set.)
71
72
RDSCKO
DAVN
I
I
73
74
X0A
X0B
—
—
75
76
RC IN1
BU IN
I
I
Rotary commander input
77
78
KEY ACK
ILLIN
I
I
Key input acknowledge
Illumination line detection input
79
80
81
TEL ATT
NCO
ACC IN
I
—
I
Telephone mute detection input
Not used.
Accessory power detection input
82
83
EMPH I
FP CLOSE
I
I
Emphasis input
Front panel close detection input
84
85
FP OPEN
BOOT DP
O
O
Front panel open control output
Display controller boot mode control output
86
87
HSTX
MD2
—
—
Connect to power supply pin.
Connect to GND.
88, 89
90
MD0, 1
RESET
—
I
Connect to power supply pin.
Microcomputer reset input
91
92
VSS
X0
—
—
GND
High speed oscillation input (3.68 MHz)
93
94
X1
VCC
—
—
High speed oscillation input (3.68 MHz)
95
96
TIMPOL
PW ON
O
O
Time poling setting (Fixed at “H” in this set.)
System power control output
97
98
ILL ON
DIRECT
O
O
Illumination power control output
Direct volume control output
99
100
ATT
ANTREM
O
O
System mute control output
Antenna remote control output
101
102
VOLCE0
VOLCE1
O
O
Input selector/tone/sub volume serial chip enable output
Electric volume serial chip enable output (L-CH)
103
104
VOLCE2
VOLCKO
O
O
Electric volume serial chip enable output (R-CH)
Volume serial clock output
105
106
VOLSO
ENC+
O
I
Volume serial data output
Rotary commander and encoder input (+)
107
108
ENC–
FM ON
I
O
Rotary commander and encoder input (–)
FM ON control output
109
AM ON
O
AM ON control output
RDS serial data input (Not used in this set.)
RDS IC data taking in detection input (Not used in this set.)
Low speed oscillation input (32.768 kHz)
Low speed oscillation input (32.768 kHz)
– 53 –
Pin No.
110
Pin Name
SEEKOUT
I/O
O
Pin Description
SEEK OUT output
111
112
AM STIN
FM STIN
I
I/O
AM stereo input (Not used in this set.)
Used in conjunction with stereo input/monaural output (FM mode)
113
114
SD IN
TU ATT
I
O
115
116
TIR D0
TIR D1
I/O
I/O
TIR IC data 0 input/output (Not used in this set.)
117
118
TIR D2
TIR D3
I/O
I/O
119
120
VSS
TIRPLAY
—
O
GND
TIR IC play mode audio select control output (Not used in this set.)
Signal detector input
Tuner mute output (Not used in this set.)
– 54 –
• IC500 HD6413002F16 (DISPLAY CONTROL)
Pin No.
1
Pin Name
VDD
I/O
—
Pin Description
2
3
SIRCS
SIRCS
I
I
4
5
LCD-RST
ILL ON
O
O
LCD controller reset control output
LCD controller power supply control output
6
7
EL ON
LCD-ST
O
O
LCD back light EL power supply control output
LCD controller information start request signal output
8
9
CS-CTL
BOOTI
O
I
SRAM master chip enable control output
Compulsory boot mode input
10
11
(RESO)
VSS
O
O
Connect to GND.
GND
12
13
LCD-SO
UNI-SO
O
O
LCD controller serial data output
BUS interface data output
14
15
LCD-RX
UNI-SI
I
I
LCD controller serial data input
BUS interface data input
16
17
UNI-CO
UNI-CI
O
I
LCD controller serial clock ouput
LCD controller serial clock input
18 – 21
22
D0 – D3
VSS
I/O
—
External RAM, ROM data bus input/output
GND
23 – 34
35
D4 – D15
VDD
I/O
—
External RAM, ROM data bus input/output
36 – 43
44
A0 – A7
VSS
O
—
External RAM, ROM address bus output
GND
45 – 56
57
58
A8 – A19
VSS
WAIT
O
—
O
GND
Not used.
59
60
(P61)
(P62)
—
—
Not used.
Not used.
61
62
NC
STBY
—
I
Not used.
Hardware standby input (Fixed at “H”.)
63
64
SYSRST
BU-IN
I
I
Reset input
65
66
VSS
EXTAL
—
O
GND
Oscillation output (14.74 MHz)
67
68
XTAL
VDD
I
—
Oscillation input (14.74 MHz)
69
70
AS
RD
—
O
Not used.
Read signal output
71
72
HWR
LWR
O
O
High write signal output
Low write signal output
73
74
MD0
MD1
I
I
Microcomputer oparation mode input (Fixed at “L”.)
Microcomputer oparation mode input (Fixed at “L”.)
75
76
MD2
AVDD
I
I
Microcomputer oparation mode input (Fixed at “H”.)
A/D converter power supply input
77
78 – 83
VREF
(AN0 – AN5)
I
—
84
85
BU-IN
PBS
I
I
Parking brake input
86
87
AVSS
BUS-ON
—
I
A/D converter GND
BUS-interface BUS-ON input
88
89
SRAM-CS
DEC-CS
O
O
SRAM chip enable output
Demodulator LSI chip enable output (Not used in this set.)
A/D converter reference voltage input
Connect to GND.
– 55 –
Pin No.
90
Pin Name
DEC-INT
I/O
O
Pin Description
Demodulator LSI initial output (Not used in this set.)
91
92
ROM-CS
VSS
O
—
PROM chip enable output
GND
93
94
UNI-REQ
LINK-OFF
O
O
Not used.
BUS interface link output
95
96
DEC-ON
DEC-CLR
O
O
Not used.
Demodulator LSI reset output (Not used in this set.)
97 – 99
100
A21 – A23
A20
O
O
Not used.
– 56 –
CDX-C90
4-2. BLOCK DIAGRAM — CD SECTION —
DRAM CONTROLLER
IC2
OPTICAL PICK-UP
KSS-520A
DIGITAL SERVO/
DIGITAL SIGNAL PROCESSOR
IC501
RF AMP, LD-APC ERROR AMP
IC1
INVERTER
3
4
7
6
PD1
PD2
E
F
2
PD
RFO 17
FE 16
TE 14
PCMD
LRCK
WDCK
BCK
C4M
DOUT
SCOR
XROF
RFCK
GTOP
WFCK
EXCK
SBSO
59 RFDC
55 FE
57 TE
CD5V
PD
LD DRIVE
Q3
1
LD
SW3
(LIMIT)
80 SSTP
LD ON 19
LD
TRACKING/FOCUS COIL DRIVE,
SLED MOTOR DRIVE
IC7
TRACKING
2
TR+
1
TR-
14 F+
FOCUS
13 F16 S+
M902
(SLED)
M
OP+
OPOP+
OPMUTE
OP+
OP-
23
24
10
11
9
20
19
71
72
73
74
89
87
85
91
84
33
28
27
25
21
20
7
6
7
8
9
10
11
12
13
14
9
10
11
7
3
2
59
4
5
6
1
42
43
44
47
48
57
58
63
DATI
LRCI
WDCI
BCKI
C4M
DIN
SCOR
XROI
RFCK
GTOP
WFCK
XWRE
WRDE
XLT
XSOE
SDTO
XQOK
GSCR
GRST
64 XRST
XRST 15
17 SSQCK
SQSO
SENS
SCLK
GFS
FOK
DATA
SPINDLE MOTOR DRIVE
IC601
M901
M
(SPINDLE)
12 DROUT+ OP IN- 25
13 DROUT- OP IN+ 24
79 MDP
VC
8
9
10
11
24
37
12
1
2
3
4
5
6
44 DATAI
43 BCKI
45 LRCKI
CLOCK GENERATOR
IC7
XTAI 14
7
1
2
SERVO 9V
2 VO
VIN 1
BATT
M903
M
(LOADING)
VC
4
5V REG
IC9
D.F. 5V
2 VO
VIN 1
9
L+
7
L-
LMOT1
LMOT2
BATT
MD 5V
VC
4
2 VO
VIN 1
CD DATA
SCLK
FOK
GFS
SENS
SCK 2
SI 2
62 IN SW
SW2
(SELF)
63 SELF SW
2
4
14 LM EJ
15 LM LOM
31 X IN
X1
10MHz
32 X OUT
BATT
VC
4
SWITCH
Q1, 5
CD5V
67
42
54
55
57
65
66
20 LD ON
9 DRV OE
10 D SW
SW1
(DISC IN)
5V REG
IC11
SWITCH
Q2, 4
BU5V
17 CDMON
18 CD ON
04
– 57 –
1
DFDTOR 24
D.IN.L
CDINL
I.OUT 14
R-CH
I-V CONVERTER
IC5
2
BCK.I
6
35 128FSO
20
5
23
9
|
7
LE.I
1
MAIN
SECTION
2
MAIN
SECTION
GND ISOLATION
IC101
2
DFSO
DFCKO
DFLAT
|
•
12 A0-A9
A0-A9 25
•
CLOCK GENERATOR
IC2(2/2)
•
34
14
38
18
1
|
D1-D4
6
ATT 47
SHIFT 48
LATCH 49
DRAM
IC4
•
DFLRCKO 23
|
46 INIT
MCKIN 17
7
1
3
5
•
28
|
2
31
24
•
D1-D4
•
25
XRAS
XWE
XCAS
XOE
4
3
23
22
26
27
32
33
X1
11.2896MHz
XRAS
XWE
XCAS
XOE
AATT
D/A 5V
5V REG
IC8
AU +5V
5V REG
IC109
DC/DC CONVERTER
DD1
DD +10V
SW4
(DOWN)
LOADING MOTOR
DRIVE
IC6
DFDTOL 59
DFBCKO 60
CF1
16.9344MHz
SDTI 45
4
6
5
3
1
2
L.P.F
IC6
D/A CONVERTER
IC4
IC2(1/2)
CD SYSTEM CONTROL
IC5
9V REG
IC10
DIGITAL FILTER
IC1
DATA 16
BCK 15
LRCK 17
46 SCK
CLOK 14
CN2
(DIGITAL OUT)
2
DOUT 18
TFDR
TRDR
FFDR
FRDR
69 SFDR
70 SRDR
1
MD 5V
ESPXQOK
ESPSDT
GRSRST
GRSCOR
ESPXWRE
ESPXRDE
ESPXLT
ESPXSOE
SCOR
CLK
TX DATA
CE
5
+10V
DD –10V
6
–10V
DD –5V
7
–5V
AU –5V
43
44
45
46
68
69
70
71
56
48
49
64
12
11
14
13
7
8
9
10
EEPROM
IC551
1
2
4
5
3
11
12
13
–5V REG
IC108
EXCK
SBSO
WFCK
MCK
SCOR
SCLK
SRDT
DQSY
VIN 2
BATT
Signal path
: CD
: DIGITAL OUT
CD CKO 59
CD RST 21
AMUT 19
FP CLOSE 7
FP OPEN 6
EMPH O 16
PW ON
P/C 1
FP CL
FP OP
EMPH
BUS ON 61
BUS SI 52
BUS CLK 51
BUS ON
BUS SI
BUS CLK
BU IN 60
RESET 30
BUS SO 53
BU IN
RESET
BUS SO
3
DISPLAY
SECTION
– 58 –
CDX-C90
4-3. BLOCK DIAGRAM — MAIN SECTION —
TUNER UNIT
TU701
CN103 (1/2)
BUS AUDIO
IN
IC771
(ANTENNA)
-2 R-CH
40
R-CH
TU 8V
9 +B (FM/AM)
10 AM+B
AM-IFOUT 14
AM-DET.OUT 12
5
7
IF IN
Q703
S-METER (FM/AM) 19
50 VSM
SD (FM/AM) 20
ST-IND 22
113 SD IN
112 FM STIN
RECEIVE/SEEK 13
110 SEEKOUT
PLL
IC721
13 IF.IN
15 AM.OSC
16 FM.OSC
DX/LCL 4
D.OUT
D.IN
CLK
CE
9 DX/LO
LPF
Q722
6
5
25 SI
26 SO
27 CKO
28 CE
4
2
32
SUB
VOLUME
31
SO
CKO
CE0
CE1
CE2
105
104
101
102
103
-3 L-CH
Q106
XI 1
XO 20
X721
7.2MHz
IC105
-3 L-CH
R-CH
R-CH
-4 R-CH
EL INVERTER DRIVE
IC550,Q553–556
DC +B
Q103
BUZZER
DRIVE
Q300
BZ300
(BUZZER)
MUTE
CONTROL
Q101
BACK-UP
CHECK ATT
Q900
D313,314
AATT
DFLAT
DFSO
DFCKO
PW ON
LAT 17
DF SO 18
CKO 19
PLL
73 X0A
ELECTRONIC
LUMINESCENT LIGHT
EL1
CD
SECTION
2
Q552
Q557
NOSE SW 12
FRONT
PANEL
(NOSE SWITCH)
74 X0B
92 X0
X300
3.68MHz
93 X1
EL ON
SITCH
Q408,411
DC +B
BATT
PN401
BU IN
EL ON
NARROW
CONTROL
Q721
BOOT
ILL ON
BOOT DP 58
BATT
4
DISPLAY
SECTION
5V REG
Q401
BU 5V
BATT
ILL ON 10V
10 WIDE
10V REG
Q402,404,406
BATT
P ON 10V
ILL ON 97
PW ON 96
POWER ON
SITCH
Q400,405
10V REG
Q403
D424
TEL ATT 79
ACC IN 81
D804
3 VO
FM 8V
AM 8V
FM ON
SITCH
Q804
DIMMER
CONTROL
Q416
ILLIN 78
9V REG
IC801
TU 8V
VIN 1
VC
2
BATT
TEST IN 56
MOT 9V
AM ON
SITCH
Q805
3 VO
VC
2
VIN 1
D600
109 AM ON
108 FM ON
1
ACC
CHECK
Q417
2
BATT
I DET 31
7 OUT
MOTOR LOCK DET AMP
IC601
MOT 9V
MOTOR VREF
CONTROL
Q601,603
20 VREF OUT2
: AM
8
M
6 RNF
IN 3
Signal Path
: FM
PANEL MOTOR DRIVE
IC600
17 OPEN OUT1
19 CLOSE
P MOT+ 29
P MOT– 30
Q605
M904
PANEL
MOTOR
5
04
MOTREF 40
– 59 –
5
TEL ATT
CONTROL
Q415
9V REG
IC602
D801
BAND
SITCH
Q803
CN403
AMP REM
BATT
ANT REM
CONTROL
Q801,802
ANTREM 100
5V REG
IC802
BATT
4
Q702
FM 5V
REAR
LINE OUT
3 6 2
X301
32.768KHz
NARROW 7
WIDE/
NARROW 24
-4 R-CH
R-CH
DIMMER 61
18 PD
FRONT
LINE OUT
IC107(2/2)
DIRECT 98
ATT 99
BEEP 15
-2 R-CH
R-CH
14
RELAY
DRIVE
Q303
16 21 22
R-CH
11
AF IF L
114 TUN ATT
VT (FM/AM) 5
RY101
16
SYSTEM CONTROL
IC300 (1/2)
DET AMP
Q107
CD L-CH
R-CH
AF.OUT L
AM-IFCOUT 11
FM-IFCOUT 21
VCO (FM/AM) 6
1
CN105
-1 L-CH
26
TONE
42
CD SECTION
AM DECODER
IC851
30
IC107(1/2)
11
DFDI
DFCKI
CS
8 FM+B
33
41
MUTE
CONTROL
Q791
Q781
MUTE
FM 8V
9
DATA
CLK
CE
R-OUT 16
ELECTRONIC VOLUME
IC104
39
R-CH
L-OUT 18
1 AM-ANT
2 FM-ANT
AM 8V
INPUT SELECT/TONE/SUB VOLUME
IC102
-1 L-CH
– 60 –
: CD
3
6
ANT REM
TEL ATT
ILL
ACC
TEST
CN103 (2/2)
SUB OUT
CDX-C90
4-4. BLOCK DIAGRAM — DISPLAY SECTION —
SYSTEM CONTROL
IC300(2/2)
DISPLAY CONTROL
IC500
CNJ301
(BUS CONTROL IN)
SIRCS 24
52 KEYIN0
53 KEYIN1
S1–19,S1A,LSW1
KEY DET
IC304
D300,301
7
1
6
2
SRAM RESET
IC301
RAMBU 55
1 OUT
VDD 2
Q309
BU 5V
CNJ300
(REMOTE IN)
77 KEY ACT
6 EECLK
5 EEDATA
RC IN1
5
3
51 RC IN0
75 RC IN1
4
ENC+
6
ENC–
2
ILL ON 10V
ILL ON 10V
ILL ON 10V
D3–6,9–12,
LSW1
ILL ON 10V
2 SIRCS
3 SIRCS
A0 36
12
9
8
11
10
13 UNI-SO
87 BUS-ON
15
17
84
64
BU IN 76
SYSRST 64
LED7,8,
31–48
(GREEN)
LED DRIVE
(AMBER/GREEN)
Q1,2
15
17
21 I/O8
D0 18
Q311
P ON 10V
LED1–6,
9–30
(AMBER)
13 I/O1
A19 56
14
21
20
22
UNI-SI
UNI-CI
BU-IN
BU-IN
DISPLAY FLASH
IC503
21
23
D15 34
29 DQ0
D0-D15
36
38
45 DQ15
D406
D409
1
RESET 90
Q310
13 COLOR
S630
(RESET)
A1-A19
66 EXTAL
1
RESET
IC400 2
X500
14.74MHz
BU 5V
67 XTAL
IC505
BU 5V
BU 5V
LED300,302
(OPEN END)
LED DRIVE
Q301
S621
(CLOSE END)
S620
(OPEN END)
25
A18
48
28 OE
A20 100
ROM-CS 91
32 POS0
26 CE
IC501
36 POS2
S623
(20 DEG)
37 POS3
LCD-RST
4
LCD-ST
7
LCD
MODULE
LCD-SO 12
84 FP OPEN
83 FP CLOSE
82 EMPH I
EN1
ROTARY
ENCODER
A0
8
16
11 WE
LWR 72
35 POS1
S622
(10 DEG)
FP OP
FP CL
EMPH
A0
D8-D15
43
45
13
12
23
25
28 A18
30
31
HIGH VOLT
CHECK
Q407
106 ENC+
107 ENC–
BUSON
UNISO
UNISI
UNICK
A0-A18
BATT
2
BATT
CHECK
D374
RC IN0
3
22 CE
29 R/W
24 OE
SRAM-CS 88
HWR 71
RD 70
1
IR
RECEIVER 2
PH1
BATT
4
6
1
SIRCS
CONTROL
Q308
3
2
1
7
BUS INTERFACE
IC302
EEPROM
IC303
EECLK 68
EEDATA 69
8
6
5
4
57 AD ON
D312
94 LINK-OFF
DISPLAY SRAM
IC504
LCD-CO 16
CONTRUST
CONTROL
Q304,305
LCD ANG 41
58 RE IN1
59 RE IN0
CD
SECTION
3
BOOTI 9
EL ON 6
ILL ON 5
BUS SO
BUS ON
BUS SI
BUS CLK
BU IN
RESET
BOOT
EL ON
ILL ON
BU IN
IC502
1
2
63 SYSRST
14 LCD-RX
04
– 61 –
– 62 –
4
MAIN
SECTION
• IC Block Diagrams
IC6 LB1638MTP-T1
IC1 CXA1791N-T4 (SERVO BOARD)
10 N.C.
GND 1
LD 1
APC
PD AMP
+
–
PD 2
VREF
1.25V
APC
LD AMP
+
–
IN1 2
20 VCC
VCC
CONTROL LOGIC
VC
19 APC ON
VCC 3
7 OUT2
IN2 4
–
+
VC
8 VS
18 RFI
VC
PD1 3
9 OUT1
RF
IV AMP1
–
+
RF
SUMMING AMP
VC
17 RFO
GND 5
6 N.C.
VC
PD2 4
–
+
VC
–
+
RF
IV AMP2
16 FE
FOCUS
ERROR AMP
GND 5
IC551 LC89170M-TLM
15 FE BIAS
VC
VC
F 6
VDD
–
+
VC
F
IV AMP
–
+
VC
14 TE
EXCK 1
TRACKING
ERROR AMP
13 EI
E 7
–
+
VC
32 WORD X 8 BIT
DUAL PORT RAM
VCC
SCOR 3
CRC
CHECKER
12 SRDT
VC BUFFER
–
+
VR 8
WFCK 4
11 SCLK
VC
NC 10
MCK 5
11 NC
TIMING
&
SYNCHRONIZATION
SIGNAL
PROTECTION
XMODE 6
10 SW2
9 SW1
GND 7
8 TEST
VSS
OSCE
A4
48 47 46 45 44 43 42 41
40
39
38 37 36 35 34 33
SDTO
XSOE
SCK
SDTI
XLT
XRDE
XWRE
SPSL
IC2 CXD2522R-T6
A5
A6
A7
A8
XOE
VC 9
13 DQSY
SBSO 2
12 EO
E
IV AMP
14 VDD
CPU INTERFACE
CPU I/F
XEMP
XWIH
AM4
AM3
AM2
AM1
AM0
VDD
XQOK
49
50
51
52
53
54
55
56
57
32
31
30
29
28
27
26
25
24
23
22
21
20
ADDRESS MONITOR
DRAM
I/F
VWA
WRITE
BASE
COUNTER
READ
BASE
COUNTER
XCAS
D4
D3
D0
D1
XWE
XRAS
A9
VDD
A0
A1
A2
A3
SELECTOR
DATA
LINKING
CONTROL
TIMING
GEN.
19 C176
DSP
I/F
DAC
I/F
DIGITAL
OUT
18 DOUT
1 2 3 4 5 6
7 8 9 10 11
12
13
14
15 16
TEST
XTAO
XTAI
BCK
DATA
17 LRCK
BCKI
VSS
DATI
LRCI
WDCI
58
59
60
61
62
63
64
WFCK
DIN
C4M
XROI
RFCK
GTOP
GSCR
SCOR
NC
NC
NC
GRST
XRST
– 91 –
1
2
WE
3
OPIN–
26 VSS
25 DQ4
24 DQ3
WRITE
CLOCK
GENERATOR
DATA INPUT
BUFFER
GND
NC
VCC
NC
NC
NC
DQ1
DQ2
OPIN+
NC
MUTE
NC
GND
IC601 BA6195FP-YT2
IC4 MB814400C-70PFTN (SERVO BOARD)
25 24 23 22 21 20
19 18 17 16 15 14
THERMAL
SHUT DOWN
DRIVER
MUTE
DATA OUTPUT
BUFFER
+
–
– +
18
17
16
15
14
1 2 3 4 5 6
7 8 9 10 11
12
13
DROUT+
A8
A7
A6
A5
A4
VCC
24 23
22
21 20 19
VCC
16
15
VCC
VCC/2
VCC/2
+
IN
SHIFT
–
IN
LEVEL
SHIFT
SHIFT
IN
LEVEL
IN
+
VCC/2
VCC/2
IN1 (–)
IN1 (+)
REG-B
7
– 92 –
8 9 10 11
VCC/2
12
13
14
OUT2-A
6
–
OUT2-B
4 5
SHIFT
PREOUT2
3
IN2 (–)
2
BIASIN
MUTE
IN2 (+)
1
PREOUT1
+
REGOUT
–
17
+
LEVEL
VCC/2
18
VCC/2
–
LEVEL
GND
VCC
25
OUT3-A
IN4 (–)
IN4 (+)
26
OUT3-B
PREOUT4
27
PREOUT3
OUT4-B
28
IN3(+)
IN3(–)
OUT4-A
IC7 BA6797FP-E2
VCC/2
+ –
DROUT–
PREADDRESS
BUFFER DECODER
MODE
CONTROL
OUT1-B
5
9
10
11
12
13
REFRESH
ADDRESS
COUNTER
GND
A9
A0
A1
A2
A3
VCC
ROW
DECODER
OUT1-A
4
– +
BOARD
BIAS
GENERATOR
NC
NC
NC
NC
NC
CLOCK
GENERATOR
1
RAS
23 CAS
22 OE
4M BIT
MEMORY
CELL
COLUMN SENSE AMP
DECODER I/O GATE
LEVEL SHIFT
+
–
OPOUT
NC
NC
BIAS
DRIN'
DRIN
CLOCK
GENERATOR
2
IN
NRGCLR
SYSM
LATCH
SHIFT
ATT
INIT
LRCKI
DATAI
BCKI
VSS
VSS
NC
INVO2
INVO1
INVI
NC
128FSO
CKVDD
DINIT
IC1 CXD8679Q (MAIN BOARD)
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
TIMING
CIRCUIT
32 INAF
S/P
IF SELD 52
OR
"0" DETECT
MUTE
CIRCUIT
IF SELC 53
31 OVFLAG
30 MUTER
NC 54
SBCKI 55
ATT
4BIT DATA
ATT
MODE
SDATAR 56
IIR
SDATAL 57
IIR
29 MUTEL
3rd order
NOISE
SHAPER
L . I . P.
28 MTPOL
ATT
x 0.75
BITSTREAM
27 DRPOL
DITHER
NC 58
FIR 4
DFDTOL 59
FIR 1
FIR 2
FIR 4
FIR 3
FIR 1
FIR 2
26 MODE
ATT
x 0.75
FIR 3
DFBCKO 60
OVERFLOW DETECTOR
25 NC
3rd order
NOISE
SHAPER
L . I . P.
24 DFDTOR
OVERFLOW DETECTOR
DFDTEN 61
23 DFLRCKO
POLALITY
22 TEST4
TEST1 62
P/S CONVERT
&
D/F-CLK GEN.
TEST2 63
21 TEST3
CLOCK
GENERATOR
VSS 64
DATA SELECT
20 VSS
DATA SELECT
7
8
9
10
11
12
13
VDD
NSDOL4
NSDOL3
NSDOL2
NSDOL1
NC
NC
VDD
VDD
NC
64FSI
NSDOR1
IC3, 4 PCM1702U-J (MAIN BOARD)
DATA
1
INPUT
INTERFACE
&
SINE CONVERTER
CIRCUIT
14
15
16
CLOCK
2
NC
3
+VDD
4
D.COM
5
–VDD
6
L.E
7
14 I OUT
NC
8
13 NC
NC
9
12 BPO DC
BY-POLR
OFFSET
CIRCUIT
+
–
MUX
8
8
16 AINL
15 AGNDL
18 NC
ZCEN 1
CS 2
SDATAI 3
16 A.COM
VD+ 4
DGND 5
15 A.COM
SCLK 6
SDATAO 7
11 +VCC
16
SERIAL
PARALLEL
REGISTER
13 VA–
12 VA+
8
8
11 AOUTR
+
–
– 93 –
14 AOUTL
CONTROL
REGISTER
MUTE 8
NC 10
19
19 REF DC
17 SERVO DC
BALANCED BALANCED
CURRENT CURRENT
SEGMENT SEGMENT
DAC A
DAC B
18
IC103, 104 CS3310-KSR
20 –VCC
REFERENCE
&
SERVO CIRCUIT
17
PLMG1
6
VDD
5
MCKIN
4
NSDOR4
3
NSDOR3
2
NSDOR2
1
PLMG2
2
10 AGNDR
MUX
9 AINR
LDLC1
LDHC1
INAO1
VRIN1
VOUT1
TIN1
TCLC1
TCLC11
TCLC12
TCO1
FDIN1
36
35 34
33
32
31
30 29 28 27 26
25
VOLUME
8dB STEP
LOUD
37
38
39
40
41
42
VOLUME
1dB STEP
TONE
FADER
BUS ON 1
BUS ON
SWITCH
RST 2
RESET
SWITCH
BATT 3
BATTERY
SWITCH
24 FNTO1
23 REO1
VCTBUFF
INPUT SW
GAIN12
GAIN11
IN14
IN13
IN12
IN11
IC302 BA8270F-E2
GAIN134
IC102 CXA1946BR
VCTBUFF
CLK 4
VREF 5
DATA 6
VCTBUFF
ZCDET
22
21
20
19
CE
CLK
DGND
GND
18
17
16
15
VCC
VCT
DATA
TIMER
13
12
11
10
RST
BUS ON
CLK IN
BU IN
9 DATA IN
GND 7
LATCH
CONTROL
LATCH
14 VCC
8 DATA OUT
45k
SHIFT
REGISTER
45k
VCTBUFF
VCTBUFF
VCTBUFF
VOLUME
8dB STEP
3
4
5
6
7 8 9 10 11
VOUT2
TIN2
TCLC2
TCLC21
TCLC22
TCO2
12
2
VRIN2
FADER
INAO2
TONE
LDLC2
GAIN234
1
VOLUME
1dB STEP
LDHC2
LOUD
IC303 AT24C16N-10SI-TR
NC
NC
DOUT
2
7
VCC
TEST
Y DEC
X DEC
EEPROM
3
8
DIN
R/W
SERIAL MUX
NC
IC503 MBM29F800BA-70PFTN97
1
LOGIC
DOUT/ACK
ADDRESS/COUNTER
DATA WORD
DATA REGISTER
INC
14 REO2
13 FNTO2
FDIN2
43
44
45
46
47
48
INPUT SW
IN21
IN22
IN23
IN24
GAIN21
GAIN22
6
LOAD
1
2
3
4
5
6
7
8
A15
A14
A13
A12
A11
A10
A9
A8
A16
48
BYTE
47
X
DECODER
8,388,608
CELL
MATRIX
Y GATE
ADDRESS
LATCH
9 NC
10 NC
Y
DECODER
I/O
BUFFER
DATA
LATCH
STB
SCL
GND 46
DQ15/A–1
45
DQ7
44
DQ14
43
DQ6
42
DQ13
41
DQ5
40
DQ12
39
DQ4
38
VCC 37
H. V. PUMP/TIMING
GND
4
EN
LOGIC
CONTROL
SERIAL
STB
LOGIC
STOP
START
5
SDA
11
12
WE
CONTROL
CIRCUIT
LOW VCC
DETECTOR CIRCUIT
RESET
13 NC
14 NC
RY/BY
15
A18
16
A17
17
A7
18
A6
19
A5
20
A4
21
A3
22
A2
23
A1
24
– 94 –
WRITE/ERASE
PULSE TIMER
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
36
35
34
33
32
31
30
29
WRITE CIRCUIT
RY/BY
BUFFER
ERASE CIRCUIT
CHIP ENABLE/
OUTPUT ENABLE
CIRCUIT
OE
28
GND 27
CE
26
A0
25
PHASE
DET
NC
NC
GND
IN2
VCC
M.BATT
18
17
16
15
14
13
19 VSS
19 IN1
20 XOUT
NC
NC
NC
NC
VREF
IC600 BA6285FP-E2
24
23
22
21
20
IC721 BU2624FV-E2
18 PD
VREF
REFERENCE
DIVIDER
17 VDD
2
4
DA
5
CD
6
P0
7
P1
9
I/O
CTL
SHIFT REGISTER LATCH
15 AMIN
IF COUNT
CTL
14 P2
20BIT COUNT
13 IFIN
P3 10
12 SD
11 P4
IC851 TA2051FN(EL)
24 23 22 21 20
NOISE
AMP
19
NOISE
DET
FILTER
AMP
18
17
16
SOM2
AF AGC
DET
SUB
GATE
NOISE AGC
DET
MAIN
GATE
PHASE
SHIFTER
BUFFER
(CH2)
(CH1)
BUFFER
IF AGC
DET
PHASE
SHIFTER
2ND IF
AMP
DET
SUB
GATE
AGC
NFB
GATE
REG
1
2
14 13
NFB
AMP
NFB
GATE
SOM1
15
3
4
5
6
7
8
MAIN
GATE
NFB
AMP
9
10
11 12
– 95 –
CONTROL
DRIVER
DRIVER
7
8
9
10
NC 11
NC 12
CE
CK
16 FMIN
PRESCALER
GND
OUT2
NC
NC
MAIN
COUNT
RNF 6
1
NC 1
NC 2
NC 3
NC 4
OUT1 5
XIN
SECTION 5
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
N
N
The components identified by
mark ! or dotted line with mark.
! are critical for safety.
Replace only with part number
specified.
Parts Color Cabinet’s Color
• Accessories and packing materials and
hardware (# mark) list are given in
the last of this parts list.
5-1. CASE SECTION
1
2
3
12
#1
1
1
1
4
14
13
15
#1
5
21
A
23
1
MG-363S-121
16
1
B
1
6
#1
1
10
7
M904
1
7
#7
22
17
1
18
19
1
1
8
1
1
A
#18
1
11
#6
9
F901
B
#6
1
20
#4
Ref. No.
Part No.
Description
1
* 2
3
* 4
* 4
3-906-712-11
3-025-797-01
1-783-269-11
A-3294-476-A
A-3294-505-A
SCREW (2.6X4) (CU), +PTT
COVER (UPPER)
CORD (WITH CONNECTOR) (POWER)
AUDIO BOARD, COMPLETE (US)
AUDIO BOARD, COMPLETE (E)
* 5
* 6
7
8
9
3-025-798-01
1-668-190-11
3-321-813-01
3-026-749-01
3-026-751-01
BRACKET (MD)
SENSOR BOARD
WASHER, COTTER POLYETHYLENE
GEAR (WORM)
GEAR (C)
10
11
12
* 13
3-026-750-01
X-3375-557-1
3-937-282-01
3-938-138-01
GEAR (B)
MOTOR ASSY
CASE (UPPER)
SHEET (E)
Remark
Ref. No.
Part No.
14
* 15
16
17
3-915-923-01
1-670-686-11
3-937-812-01
1-783-271-11
18
* 19
20
21
22
23
F901
M904
– 96 –
Description
Remark
SCREW, GROUND POINT
EL BOARD
CASE (LOWER)
CORD (WITH CONNECTOR) (RCA)
1-783-271-21 CORD (WITH CONNECTOR) (RCA)
3-025-805-01
1-783-270-21
1-790-088-11
3-029-367-01
3-029-989-01
PANEL, REAR
CORD, POWER
CORD (WITH CONNECTOR) (INVERTER)
COVER (MD)
CUSHION (COIL)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
A-3301-552-A MOTOR SUB ASSY (PANEL)
5-2. FRONT PANEL SECTION
#3
69
#3
71
64
68
70
63
72
56
62
61
60
55
54
66
65
51
59
52
58
53
67
57
Ref. No.
Part No.
Description
51
52
53
54
55
3-025-811-01
3-025-820-01
3-025-793-01
3-025-815-01
3-025-808-01
BUTTON (SOURCE)
FRAME (FRONT), ORNAMENT
KNOB (VOL)
LEVER (SEEK/AMS)
PLATE (SEEK/AMS), LIGHT GUIDE
56
57
58
59
60
3-025-814-01
3-349-825-61
3-025-817-01
3-025-818-01
3-026-388-01
BRACKET (FRAME)
SCREW
BUTTON (10 KEY)
BUTTON (FUNCTION)
BUTTON (MODE)
61
62
3-025-816-01 BUTTON (RELEASE)
3-934-415-01 SPRING (RELEASE)
Remark
Ref. No.
Part No.
Description
63
64
65
66
67
1-669-127-11
3-025-807-01
3-026-389-01
3-025-810-01
X-3375-934-1
FLEXIBLE SW BOARD
PANEL, FRONT BACK
COVER (SOURCE)
SHEET (FRONT), ADHESIVE
PANEL SUB ASSY, FRONT (US)
67
68
69
* 70
* 71
X-3376-540-1
3-938-230-01
1-803-056-11
3-029-132-01
3-029-749-01
PANEL SUB ASSY, FRONT (E)
SHEET (BLIND)
LIQUID CRYSTAL MODULE
SHEET (MODE)
SHEET (SOURCE)
* 72
3-030-385-01 SHEET (10 KEY)
– 97 –
Remark
5-3. CHASSIS SECTION
121 #6
113
114
122
not
supplied
#11
120
#11
113
#10
TU701
#2
115
102
110
not
supplied
105
107
104
103
124
111
123
116
106 #9
109
108
101
112
#8
119
118
117
#4
#8
Ref. No.
Part No.
Description
101
102
103
104
105
X-3375-552-1
X-3375-555-1
3-934-758-01
3-934-756-01
3-031-106-01
PANEL ASSY, SUB
PANEL ASSY, BASE
SPRING (A)
ARM (LOCK)
SPRING (B90)
*
*
*
*
*
106
107
108
109
110
3-934-757-01
3-934-755-01
3-909-607-01
1-778-182-11
1-670-154-11
HOLDER (LOCK)
SHAFT (LOCK)
SCREW
SOCKET, CONNECTOR 18P
FLEXIBLE BOARD
* 111
112
113
3-025-782-01 COVER (FLEXIBLE)
3-025-783-01 SCREW (M1.7), STEP
3-906-713-01 SCREW (+PTT), GROUND POINT
Remark
112
Ref. No.
Part No.
Description
114
114
115
116
117
A-3313-956-A
A-3317-107-A
X-3376-177-1
3-026-748-01
X-3375-551-1
MAIN BOARD, COMPLETE (US)
MAIN BOARD, COMPLETE (E)
BRACKET (TRANSISTOR) ASSY
SHEET (INSULATING 90)
CHASSIS ASSY
118
119
120
121
* 122
X-3375-553-1
X-3375-554-1
X-3375-756-1
X-3375-556-1
3-025-792-01
LEVER (L) ASSY
LEVER (R) ASSY
CHASSIS (FRONT) ASSY
SHAFT (PINION) ASSY
BRACKET (SHAFT PINION)
123
124
TU701
– 98 –
1-777-246-31 CORD (WITH CONNECTOR) (ANT)
3-906-712-11 SCREW (2.6X6) (CU), +PTT
A-3282-045-A TUNER UNIT (TUX-012(E))
Remark
5-4. CD MECHANISM SECTION (1)
(MG-363S-121)
#13
152
#13
154
161 153
162
157
161
159
151
162
#14
155
158
156
163
C
M903
164
C
165
160
#15
#14
not supplied
#13
166
#12
#12
Ref. No.
Part No.
Description
* 151
* 152
153
154
155
1-659-836-11
A-3291-816-B
3-931-909-01
X-3371-501-1
3-338-737-01
* 156
157
158
159
1-659-837-11
X-3371-502-1
A-3301-203-A
3-931-908-01
Remark
Ref. No.
Part No.
Description
DISC IN SW BOARD
CHASSIS (T) SUB ASSY
SPRING (LR), TENSION
LEVER (L) ASSY
SCREW (2X3), + PS
160
161
162
* 163
164
3-931-902-04
3-936-756-01
3-321-393-01
3-939-139-01
3-931-916-01
ARM (ROLLER)
ROLLER (D)
WASHER, STOPPER
SPACER
SPRING (RA), TENSION
LOAD SW BOARD
LEVER (R) ASSY
ROLLER ASSY
GUIDE (DISC)
* 165
* 166
M903
A-3313-381-A SERVO BOARD, COMPLETE
3-007-530-01 BRACKET (MOTOR)
A-3291-676-A MOTOR SUB ASSY, LOADING (LOADING)
– 99 –
Remark
(MG-363S-121)
204
#15
201
205
206
207
214
D
208
210
203
212
213
211
D
209
202
202
202
Ref. No.
201
202
203
* 204
205
206
207
Part No.
3-931-893-01
3-931-897-01
3-931-879-02
3-913-404-11
3-931-894-01
Description
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
BRACKET (CP)
3-931-895-01 SPRING (CH), TENSION
3-931-898-01 SPRING (FL), COMPRESSION
Remark
Ref. No.
Part No.
Description
208
* 209
210
211
212
3-931-914-01
A-3291-677-G
3-931-883-01
3-931-881-01
3-931-882-02
SPRING (ANGLE), TENSION
CHASSIS (M) ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
213
214
– 100 –
3-007-537-01 WHEEL (U), WORM
3-931-898-11 SPRING (FL), COMPRESSION
Remark
(MG-363S-121)
251
#16
M901
257
252
#15
M902
253
258
255
#17
256
259
260
#13
254
263
261
262
#13
Ref. No.
Part No.
Description
* 251
252
253
254
* 255
X-3374-022-1
3-931-829-01
X-3371-504-1
3-931-832-01
1-659-835-12
CHASSIS (OP) (O/S) ASSY
SPRING (SL), PLATE
BASE (DRIVING) ASSY
GEAR (SL MIDWAY)
LIMIT SW BOARD
256
257
* 258
3-338-737-01 SCREW (2X3), + PS
1-659-880-11 MOTOR FLEXIBLE BOARD
1-659-834-11 SUB BOARD
Remark
specified.
Ref. No.
Part No.
Description
259
! 260
261
262
263
3-909-607-01
8-848-402-02
3-931-834-01
1-659-881-11
A-3291-669-A
SCREW
PICK-UP, OPTICAL KSS-520A/J2NP
SPRING (FEED), PLATE
PICK-UP FLEXIBLE BOARD
SHAFT (FEED) ASSY
M901
M902
– 101 –
X-3373-096-1 MOTOR ASSY (SPINDLE)
A-3301-107-A MOTOR ASSY, SLED (SLED)
Remark
SECTION 6
ELECTRICAL PARTS LIST
AUDIO
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
Ref. No.
Part No.
*
*
A-3294-476-A AUDIO BOARD, COMPLETE (US)
A-3294-505-A AUDIO BOARD, COMPLETE (E)
**********************
Description
Remark
Ref. No.
< CAPACITOR >
specified.
When indicating parts by reference
number, please include the board.
Part No.
Description
C149
C150
C151
C152
C153
1-124-721-11
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
100PF
100PF
100PF
100PF
20%
5%
5%
5%
5%
Remark
50V
50V
50V
50V
50V
C103
C104
C105
C106
C107
1-115-339-11
1-115-339-11
1-104-535-11
1-104-535-11
1-104-535-11
CERAMIC CHIP
CERAMIC CHIP
FILM CHIP
FILM CHIP
FILM CHIP
0.1uF
0.1uF
470PF
470PF
470PF
10%
10%
5%
5%
5%
50V
50V
50V
50V
50V
C154
C155
C156
C157
C158
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C108
C109
C110
C111
C112
1-104-535-11
1-124-721-11
1-124-721-11
1-104-543-11
1-104-543-11
FILM CHIP
ELECT
ELECT
FILM CHIP
FILM CHIP
470PF
10uF
10uF
0.0022uF
0.0022uF
5%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C159
C162
C163
C164
C165
1-163-251-11
1-124-698-11
1-124-698-11
1-115-651-11
1-115-651-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
100PF
100uF
100uF
100uF
100uF
5%
20%
20%
20%
20%
50V
25V
25V
16V
16V
C113
C114
C115
C116
C117
1-104-851-11
1-104-851-11
1-115-340-11
1-115-340-11
1-163-251-11
TANTAL. CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.22uF
0.22uF
100PF
20%
20%
10%
10%
5%
10V
10V
25V
25V
50V
C166
C167
C168
C169
C170
1-163-009-11
1-163-009-11
1-115-339-11
1-164-505-11
1-115-340-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
CERAMIC CHIP
0.001uF
0.001uF
0.1uF
2.2uF
0.22uF
10%
10%
10%
10%
50V
50V
50V
16V
25V
C118
C119
C120
C121
C122
1-115-339-11
1-115-339-11
1-104-953-11
1-104-953-11
1-110-454-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT CHIP
0.1uF
0.1uF
47uF
47uF
10uF
10%
10%
20%
20%
20%
50V
50V
16V
16V
16V
C171
1-115-340-11 CERAMIC CHIP
0.22uF
10%
25V
< CONNECTOR >
*
*
*
*
CN101
CN102
CN103
CN104
CN105
1-784-608-11
1-506-946-11
1-506-988-11
1-506-946-11
1-506-988-11
PLUG, CONNECTOR 16P
PIN, CONNECTOR 4P
PIN, CONNECTOR (PC BOARD) 6P
PIN, CONNECTOR 4P
C123
C124
C125
C126
C127
1-104-851-11
1-104-851-11
1-164-346-11
1-164-732-11
1-164-732-11
TANTAL. CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC
CERAMIC
10uF
10uF
1uF
0.1uF
0.1uF
20%
20%
20%
20%
10V
10V
16V
50V
50V
C128
C129
C130
C131
C132
1-164-732-11
1-164-732-11
1-115-339-11
1-115-339-11
1-164-732-11
CERAMIC
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
20%
10%
10%
20%
50V
50V
50V
50V
50V
D101
D102
D103
C133
C134
C135
C142
C143
1-164-732-11
1-164-732-11
1-164-732-11
1-124-721-11
1-124-721-11
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT
0.1uF
0.1uF
0.1uF
10uF
10uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
IC101
IC102
IC103
IC104
IC105
8-759-711-85
8-752-082-16
8-759-539-56
8-759-539-56
8-759-711-85
IC
IC
IC
IC
IC
NJM4580E-D
CXA1946BR
CS3310-KSR
CS3310-KSR
NJM4580E-D
C144
C145
C146
C147
C148
1-124-721-11
1-124-721-11
1-124-721-11
1-124-721-11
1-124-721-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
10uF
10uF
10uF
10uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
IC106
IC107
IC108
IC109
8-759-481-71
8-759-481-71
8-759-373-92
8-759-373-79
IC
IC
IC
IC
OP275GP
OP275GP
TA79005SB
TA7805SB
< DIODE >
8-719-988-62 DIODE 1SS355
8-719-988-62 DIODE 1SS355
8-719-056-76 DIODE UDZ-TE-17-3.6B
< IC >
– 102 –
AUDIO
Ref. No.
Part No.
Description
Remark
Ref. No.
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-921-25
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
FMC2
DTC314TKH04
DTC314TKH04
DTC314TKH04
DTC314TKH04
Q106
Q107
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
DISC IN SW
EL
Part No.
Description
R146
R147
R148
R149
R150
1-260-008-11
1-216-033-00
1-216-033-00
1-259-987-11
1-259-987-11
CARBON MELF
METAL CHIP
METAL CHIP
CARBON MELF
CARBON MELF
10K
220
220
220
220
2%
5%
5%
2%
2%
Remark
1/8W
1/10W
1/10W
1/8W
1/8W
R151
R152
R153
R154
R155
1-259-987-11
1-259-987-11
1-216-081-00
1-216-081-00
1-260-012-11
CARBON MELF
CARBON MELF
METAL CHIP
METAL CHIP
CARBON MELF
220
220
22K
22K
22K
2%
2%
5%
5%
2%
1/8W
1/8W
1/10W
1/10W
1/8W
R156
R157
R158
R165
R166
1-260-012-11
1-260-012-11
1-260-012-11
1-216-238-00
1-216-238-00
CARBON MELF
CARBON MELF
CARBON MELF
RES,CHIP
RES,CHIP
22K
22K
22K
47K
47K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R167
R168
R169
R170
R171
1-216-210-00
1-216-210-00
1-216-825-11
1-216-825-11
1-216-825-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
2.2K
2.2K
2.2K
2%
2%
5%
5%
5%
1/8W
1/8W
1/16W
1/16W
1/16W
R172
R173
R174
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
2.2K
2.2K
2.2K
5%
5%
5%
1/16W
1/16W
1/16W
< RESISTOR >
R103
R104
R105
R106
R107
1-260-004-11
1-260-004-11
1-260-004-11
1-260-004-11
1-260-004-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
4.7K
4.7K
4.7K
4.7K
4.7K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R108
R109
R110
R113
1-260-004-11
1-260-004-11
1-260-004-11
1-216-828-11
CARBON MELF
CARBON MELF
CARBON MELF
METAL CHIP
4.7K
4.7K
4.7K
3.9K
2%
2%
2%
5%
R114
1-216-828-11 METAL CHIP
3.9K
5%
1/8W
1/8W
1/8W
1/16W
(E)
1/16W
(E)
R117
R118
1-216-864-11 METAL CHIP
1-216-821-11 METAL CHIP
0
1K
5%
5%
R118
1-216-864-11 METAL CHIP
0
5%
R119
R120
1-216-864-11 METAL CHIP
1-216-821-11 METAL CHIP
0
1K
5%
5%
R120
1-216-864-11 METAL CHIP
0
5%
R121
R122
R123
R124
1-216-864-11
1-216-864-11
1-216-097-00
1-216-097-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
0
0
100K
100K
5%
5%
5%
5%
1/16W
(US)
1/16W
1/16W
1/10W
1/10W
R125
R126
R127
R128
R129
1-216-097-00
1-208-399-61
1-208-399-61
1-216-097-00
1-216-057-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
100K
27
27
100K
2.2K
5%
2%
2%
5%
5%
1/10W
1/8W
1/8W
1/10W
1/10W
R130
R135
R136
R137
R138
1-216-101-00
1-260-004-11
1-260-004-11
1-260-004-11
1-260-004-11
METAL CHIP
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
150K
4.7K
4.7K
4.7K
4.7K
5%
2%
2%
2%
2%
1/10W
1/8W
1/8W
1/8W
1/8W
R139
R140
R141
R142
R143
1-260-004-11
1-260-004-11
1-260-008-11
1-260-008-11
1-260-008-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
4.7K
4.7K
10K
10K
10K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R144
R145
1-260-008-11 CARBON MELF
10K
10K
2%
2%
1/8W
1/8W
1/16W
1/16W
(E)
1/16W
(US)
1/16W
1/16W
(E)
< RELAY >
RY101 1-755-061-11 RELAY
*************************************************************
1-659-836-11 DISC IN SW BOARD
****************
*
< SWITCH >
SW1
1-572-288-11 SWITCH, PUSH (DISC IN)
SW2
1-572-288-11 SWITCH, PUSH (SELF)
*************************************************************
1-670-686-11 EL BOARD
*********
*
< CAPACITOR >
C551
C552
C553
C554
C555
1-124-233-11
1-115-339-11
1-126-925-11
1-163-037-11
1-126-962-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.1uF
470uF
0.022uF
3.3uF
20%
10%
20%
10%
20%
16V
50V
10V
25V
50V
C556
C557
0.1uF
0.001uF
10%
10%
50V
50V
< CONNECTOR >
* CN550
CN551
– 103 –
1-564-508-11 PLUG, CONNECTOR 5P
1-564-505-11 PLUG, CONNECTOR 2P
EL
Ref. No.
LIMIT SW
Part No.
LOAD SW
MAIN
Description
Remark
< DIODE >
D550
D551
D552
D553
D554
8-719-978-24
8-719-977-21
8-719-988-62
8-719-060-48
8-719-978-24
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-5.6A
DTZ8.2C
1SS355
RB751V-40TE-17
DTZ-TT11-5.6A
D555
8-719-056-83 DIODE UDZ-TE-17-6.8B
*
X-3376-177-1 BRACKET (TRANSISTOR) ASSY
7-685-146-11 SCREW +P 3X8 TYPE2 NON-SLIT
7-685-792-09 SCREW +PTT 2.6X6 (S)
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Description
Remark
1-504-920-11 BUZZER
8-759-495-75 IC NJM317F
< CAPACITOR >
Q552
Q553
Q554
Q555
Q556
8-729-900-53
8-729-026-68
8-729-900-53
8-729-106-60
8-729-046-09
DTC114EK
2SD2525(TP)
DTC114EK
2SB1115A
2SD1864-R
Q557
8-729-021-94 FET 2SK1657-T1B
< RESISTOR >
C1
C3
C4
C5
C6
1-104-914-11
1-104-852-11
1-104-851-11
1-115-339-11
1-115-339-11
TANTAL. CHIP
TANTAL. CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
22uF
10uF
0.1uF
0.1uF
20%
20%
20%
10%
10%
16V
10V
10V
50V
50V
C7
C9
C12
C13
C14
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-124-910-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.1uF
47uF
10%
10%
10%
10%
20%
50V
50V
50V
50V
50V
R552
R553
R555
R556
R557
1-216-214-00
1-216-214-00
1-216-158-00
1-216-158-00
1-216-003-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
4.7K
4.7K
22
22
12
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/10W
C15
C16
C17
C18
C19
1-163-291-11
1-163-287-11
1-104-852-11
1-115-651-11
1-115-651-11
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
ELECT
ELECT
15PF
10PF
22uF
100uF
100uF
5%
5%
20%
20%
20%
50V
50V
10V
16V
16V
R558
R559
R560
R561
R562
1-216-097-00
1-216-057-00
1-216-068-00
1-216-174-00
1-216-097-00
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
100K
2.2K
6.2K
100
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
C20
C21
C22
C23
C24
1-124-698-11
1-104-852-11
1-104-852-11
1-104-852-11
1-104-852-11
ELECT
TANTAL. CHIP
TANTAL. CHIP
TANTAL. CHIP
TANTAL. CHIP
100uF
22uF
22uF
22uF
22uF
20%
20%
20%
20%
20%
25V
10V
10V
10V
10V
R563
1-216-097-00 RES,CHIP
100K
5%
1/10W
C25
C26
C27
C28
C29
1-115-651-11
1-115-651-11
1-124-698-11
1-104-852-11
1-104-852-11
ELECT
ELECT
ELECT
TANTAL. CHIP
TANTAL. CHIP
100uF
100uF
100uF
22uF
22uF
20%
20%
20%
20%
20%
16V
16V
25V
10V
10V
C30
C31
C32
C33
C34
1-104-852-11
1-110-359-11
1-110-355-11
1-115-651-11
1-164-732-11
TANTAL. CHIP
MYLAR
MYLAR
ELECT
CERAMIC
22uF
0.0047uF
0.0022uF
100uF
0.1uF
20%
5%
5%
20%
20%
10V
50V
50V
16V
50V
C35
C36
C37
C38
C39
1-164-732-11
1-115-651-11
1-164-732-11
1-164-732-11
1-110-355-11
CERAMIC
ELECT
CERAMIC
CERAMIC
MYLAR
0.1uF
100uF
0.1uF
0.1uF
0.0022uF
20%
20%
20%
20%
5%
50V
16V
50V
50V
50V
C40
C41
C42
C43
C44
1-110-359-11
1-115-339-11
1-115-339-11
1-115-339-11
1-124-910-11
MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.0047uF
0.1uF
0.1uF
0.1uF
47uF
5%
10%
10%
10%
20%
50V
50V
50V
50V
50V
C46
1-124-698-11 ELECT
100uF
20%
25V
< TRANSFORMER >
T550
1-431-831-11 TRANSFORMER, OSCILLATION (EL)
*************************************************************
1-659-835-12 LIMIT SW BOARD
***************
< SWITCH >
SW3
1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
*
A-3313-956-A MAIN BOARD, COMPLETE (US)
A-3317-107-A MAIN BOARD, COMPLETE (E)
*********************
BZ300
< TRANSISTOR >
*
Part No.
< BUZZER >
< IC >
IC550
Ref. No.
*
*
1-659-837-11 LOAD SW BOARD
***************
< SWITCH >
SW4
1-572-288-11 SWITCH, PUSH (DOWN)
*************************************************************
– 104 –
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C47
C48
C49
C50
C51
1-115-339-11
1-124-910-11
1-115-339-11
1-115-339-11
1-164-732-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
0.1uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
20%
50V
50V
50V
50V
50V
C412
C413
C415
C417
C418
1-163-263-11
1-115-866-11
1-124-703-11
1-104-951-11
1-163-009-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
330PF
4.7uF
2200uF
10uF
0.001uF
5%
20%
20%
20%
10%
50V
35V
25V
16V
50V
C52
C53
C54
C55
C56
1-124-710-11
1-115-339-11
1-164-732-11
1-124-710-11
1-115-651-11
ELECT
CERAMIC CHIP
CERAMIC
ELECT
ELECT
100uF
0.1uF
0.1uF
100uF
100uF
20%
10%
20%
20%
20%
35V
50V
50V
35V
16V
C420
C421
C422
C500
C501
1-163-263-11
1-163-263-11
1-163-263-11
1-163-021-11
1-104-913-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
330PF
330PF
330PF
0.01uF
10uF
5%
5%
5%
10%
20%
50V
50V
50V
50V
16V
C57
C58
C59
C60
C61
1-115-339-11
1-115-581-11
1-115-581-11
1-164-346-11
1-163-113-00
CERAMIC CHIP
TANTAL. CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
100uF
1uF
68PF
10%
20%
20%
5%
50V
16V
16V
16V
50V
C502
C503
C504
C505
C506
1-163-021-11
1-163-021-11
1-163-021-11
1-104-913-11
1-104-913-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
TANTAL. CHIP
0.01uF
0.01uF
0.01uF
10uF
10uF
10%
10%
10%
20%
20%
50V
50V
50V
16V
16V
C63
C64
C65
C66
C300
1-163-239-11
1-163-235-11
1-163-239-11
1-163-239-11
1-163-229-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33PF
22PF
33PF
33PF
12PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C507
C508
C509
C510
C511
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C301
C303
C304
C305
C306
1-163-231-11
1-107-823-11
1-163-021-11
1-104-851-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
15PF
0.47uF
0.01uF
10uF
0.01uF
5%
10%
10%
20%
10%
50V
16V
50V
10V
50V
C512
C600
C601
C602
C603
1-163-021-11
1-115-339-11
1-115-339-11
1-115-581-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
100uF
0.1uF
10%
10%
10%
20%
10%
50V
50V
50V
16V
50V
C309
C310
C311
C312
C314
1-124-233-11
1-163-009-11
1-163-009-11
1-115-339-11
1-163-021-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.001uF
0.001uF
0.1uF
0.01uF
20%
10%
10%
10%
10%
16V
50V
50V
50V
50V
C604
C605
C606
C607
C704
1-115-339-11
1-115-339-11
1-115-339-11
1-163-009-11
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.001uF
22PF
10%
10%
10%
10%
5%
50V
50V
50V
50V
50V
C315
C316
C318
C319
C320
1-163-021-11
1-115-339-11
1-163-021-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C706
C707
C708
C709
C710
1-128-421-11
1-128-421-11
1-128-421-11
1-163-021-11
1-163-021-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
47uF
0.01uF
0.01uF
20%
20%
20%
10%
10%
16V
16V
16V
50V
50V
C371
C372
C373
C374
C375
1-115-339-11
1-163-251-11
1-163-251-11
1-163-251-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
100PF
100PF
100PF
10%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C711
C712
C721
C722
C723
1-163-021-11
1-162-964-11
1-128-421-11
1-162-970-11
1-163-234-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
47uF
0.01uF
20PF
10%
10%
20%
10%
5%
50V
50V
16V
25V
50V
C376
C377
C401
C402
C403
1-163-251-11
1-163-021-11
1-124-234-00
1-125-710-11
1-128-526-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
DOUBLE LAYERS
ELECT
100PF
0.01uF
22uF
0.1F
100uF
5%
10%
20%
20%
50V
50V
16V
5.5V
16V
C724
C725
C726
C727
C728
1-163-231-11
1-162-964-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
15PF
0.001uF
100PF
100PF
100PF
5%
10%
5%
5%
5%
50V
50V
50V
50V
50V
C404
C405
C406
C407
C408
1-115-339-11
1-124-234-00
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
50V
16V
50V
50V
50V
C733
C771
C774
C775
1-115-330-11
1-135-091-00
1-128-436-11
1-104-553-11
FILM
TANTALUM CHIP
ELECT
FILM CHIP
0.22uF
1uF
1uF
0.015uF
5%
20%
20%
5%
50V
16V
50V
16V
C775
1-104-555-11 FILM CHIP
0.022uF
5%
16V
C409
C410
C411
1-115-866-11 ELECT
Remark
0.1uF
0.01uF
4.7uF
10%
10%
20%
50V
50V
35V
Ref. No.
Remark
(E)
(US)
C776
– 105 –
1uF
16V
MAIN
Ref. No.
Part No.
Description
C779
C781
C784
C785
1-163-037-11
1-135-091-00
1-128-436-11
1-104-553-11
CERAMIC CHIP
TANTALUM CHIP
ELECT
FILM CHIP
C785
1-104-555-11 FILM CHIP
Remark
Ref. No.
0.022uF
1uF
1uF
0.015uF
10%
20%
20%
5%
25V
16V
50V
16V
*
*
*
*
0.022uF
5%
16V
(E)
(US)
CN400
CN401
CN402
CN403
CN600
Part No.
Description
1-506-999-11
1-506-986-11
1-506-984-11
1-750-141-11
1-770-626-21
PIN, CONNECTOR 9P
* CN701 1-506-984-11 PIN, CONNECTOR (PC BOARD) 2P
* CN801 1-506-998-11 PIN, CONNECTOR (PC BOARD) 2P
CNJ301 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)
C789
C792
C801
C802
C804
1-163-037-11
1-163-809-11
1-104-953-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.047uF
47uF
0.01uF
0.01uF
10%
10%
20%
10%
10%
25V
25V
16V
25V
25V
C805
C806
C807
C808
C809
1-104-951-11
1-104-951-11
1-104-951-11
1-162-970-11
1-124-233-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
10uF
10uF
10uF
0.01uF
10uF
20%
20%
20%
10%
20%
16V
16V
16V
25V
16V
CP701
C813
C828
C851
C852
C853
1-163-263-11
1-124-233-11
1-165-176-11
1-107-826-11
1-162-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
10uF
0.047uF
0.1uF
0.001uF
5%
20%
10%
10%
10%
50V
16V
16V
16V
50V
D300
D301
D302
D303
D304
8-719-988-62
8-719-988-62
8-719-988-62
8-719-105-99
8-719-056-93
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355
1SS355
1SS355
RD6.2M-B1
UDZ-TE-17-18B
C854
C855
C856
C857
C858
1-164-227-11
1-135-213-21
1-163-245-11
1-163-986-00
1-162-970-11
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
3.3uF
56PF
0.027uF
0.01uF
10%
20%
5%
10%
10%
25V
25V
50V
25V
25V
D305
D306
D309
D310
D311
8-719-056-93
8-719-105-99
8-719-066-17
8-719-066-17
8-719-066-17
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-18B
RD6.2M-B1
FTZ6.8E-T148
FTZ6.8E-T148
FTZ6.8E-T148
C859
C860
C861
C862
C863
1-104-913-11
1-162-970-11
1-165-176-11
1-164-227-11
1-162-970-11
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.01uF
0.047uF
0.022uF
0.01uF
20%
10%
10%
10%
10%
16V
25V
16V
25V
25V
D312
D313
D314
D370
D371
8-719-988-62
8-719-988-62
8-719-988-62
8-719-976-99
8-719-976-99
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355
1SS355
1SS355
DTZ5.1B
DTZ5.1B
C864
C865
C866
C867
C868
1-126-572-11
1-164-227-11
1-162-962-11
1-162-962-11
1-115-339-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.022uF
470PF
470PF
0.1uF
20%
10%
10%
10%
10%
35V
25V
50V
50V
50V
D372
D373
D374
D400
D401
8-719-056-83
8-719-056-83
8-719-914-44
8-719-975-40
8-719-988-62
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
DAP202K
RB411D
1SS355
C891
C893
C894
C895
1-104-760-11
1-115-185-11
1-163-021-11
1-163-809-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.033uF
0.01uF
0.047uF
10%
10%
10%
10%
50V
50V
50V
25V
D402
D403
D404
D405
D406
8-719-056-88
8-719-977-04
8-719-056-88
8-719-978-69
8-719-988-62
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-11B
DTZ5.6C
UDZ-TE-17-11B
DTZ-TT11-16B
1SS355
D409
D410
D412
D414
D415
8-719-988-62
8-719-056-83
8-719-056-83
8-719-914-43
8-719-914-43
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
DAN202K
DAN202K
D416
D417
D418
D419
D422
8-719-056-83
8-719-313-73
8-719-313-73
8-719-028-74
8-719-056-83
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-6.8B
SFPB-52
SFPB-52
NSQ03A04
UDZ-TE-17-6.8B
D423
8-719-988-62 DIODE 1SS355
< JACK >
CNJ300 1-778-831-11 JACK 7P (REMOTE IN)
< DISCHARGE GAP >
1-519-504-11 GAP, DISCHARGE
< DIODE >
< FILTER >
CF1
1-577-685-11 FILTER, CRYSTAL (16.9344MHz)
< CONNECTOR >
CN1
CN2
* CN3
CN4
* CN5
1-764-617-12
1-695-546-11
1-506-611-11
1-784-609-11
1-506-985-11
PLUG, CONNECTOR (DIGITAL OUT)
PIN, CONNECTOR 8P
RECEPTACLE, CONNECTOR 16P
* CN6
CN300
1-506-999-11 PIN, CONNECTOR (PC BOARD) 3P
1-784-829-21 CONNECTOR, FPC 21P
Remark
– 106 –
Ver 1.1
MAIN
Ref. No.
Part No.
Description
Part No.
Description
D424
D600
D604
D605
D791
8-719-914-43
8-719-914-43
8-719-988-62
8-719-988-62
8-719-422-12
DIODE
DIODE
DIODE
DIODE
DIODE
DAN202K
DAN202K
1SS355
1SS355
MA8039
Remark
Ref. No.
IC601
IC602
IC721
IC771
IC801
8-759-981-69
8-759-363-82
8-759-448-85
8-759-064-92
8-759-363-82
IC
IC
IC
IC
IC
D801
D804
D900
8-719-914-43 DIODE DAN202K
8-719-975-40 DIODE RB411D
8-719-988-62 DIODE 1SS355
IC802
IC851
8-759-525-12 IC PQ1R47
8-759-349-99 IC TA2051FN
Remark
LM2904M
PQ09TZ1U
BU2624FV-E2
NJM5532M-D
PQ09TZ1U
< COIL >
< DC/DC CONVERTER >
DD1
1-475-643-11 CONVERTER UNIT, DC/DC
< FERRITE BEAD >
FB1
FB2
FB3
FB4
FB5
1-543-775-11
1-414-235-11
1-500-239-21
1-500-445-21
1-500-445-21
FERRITE, EMI (SMD)
INDUCTOR, FERRITE BEAD
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FB6
FB7
FB401
FB402
FB403
1-500-445-21
1-500-445-21
1-500-445-21
1-500-445-21
1-500-445-21
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FB404
FB405
FB406
FB407
1-500-445-21
1-500-445-21
1-500-445-21
1-500-445-21
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
< IC >
L1
L2
L3
L5
L300
1-410-208-21
1-414-400-11
1-414-398-11
1-412-056-11
1-414-400-11
INDUCTOR CHIP
INDUCTOR
INDUCTOR
INDUCTOR CHIP
INDUCTOR
22uH
22uH
10uH
4.7uH
22uH
L401
L500
L501
L502
L721
1-414-712-21
1-414-400-11
1-414-400-11
1-414-400-11
1-414-400-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
1mH
22uH
22uH
22uH
22uH
L851
1-414-400-11 INDUCTOR
22uH
< DIODE >
LED300 8-719-033-13 LED CL-170Y-CD-T (OPEN END)
LED302 8-719-033-13 LED CL-170Y-CD-T (OPEN END)
< TRAP COIL >
LF771
LF781
1-416-717-11 COIL, TRAP
1-416-717-11 COIL, TRAP
IC1
IC2
IC3
IC4
IC5
8-759-495-99
8-759-242-70
8-759-253-90
8-759-253-90
8-759-064-92
IC
IC
IC
IC
IC
CXD8679AQ
TC7WU04F
PCM1702U-J
PCM1702U-J
NJM5532M-D
PS1
IC6
IC7
IC8
IC9
IC10
8-759-064-92
8-759-242-70
8-759-373-79
8-759-157-21
8-759-054-12
IC
IC
IC
IC
IC
NJM5532M-D
TC7WU04F
TA7805SB
PQ05TZ11
PQ09RA1
Q300
Q301
Q303
Q304
Q305
8-729-900-53
8-729-900-53
8-729-900-53
8-729-026-53
8-729-905-35
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EK
DTC114EK
DTC114EK
2SA1576A-T106-QR
2SC4081T106R
IC11
IC300
IC301
IC302
IC303
8-759-157-21
8-759-542-47
8-759-495-76
8-759-449-89
8-759-253-82
IC
IC
IC
IC
IC
PQ05TZ11
MB90F574PFV-G-139-BND
RN5VD33AA-TL
BA8270F-E2
AT24C16N-10SI-TR
Q308
Q309
Q310
Q311
Q400
8-729-027-23
8-729-027-23
8-729-900-53
8-729-900-53
8-729-044-95
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114EKA-T146
DTA114EKA-T146
DTC114EK
DTC114EK
2SB1571-T1
IC304
IC400
IC500
IC501
IC502
8-759-242-70
8-759-443-41
8-759-337-66
8-759-035-93
8-759-360-79
IC
IC
IC
IC
IC
TC7WU04F
RH5VL40AA-T1C
HD6413002F16
SC7S32F
TC7W14F(TE12R)
Q401
Q402
Q403
Q404
Q405
8-729-040-17
8-729-106-68
8-729-106-68
8-729-904-48
8-729-901-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2164-K
2SD1615A-GP
2SD1615A-GP
DTB113EK
DTC124EK
IC503
IC504
IC505
IC600
8-759-544-63
8-759-536-92
8-759-234-20
8-759-276-89
IC
IC
IC
IC
MBM29F800BA-70PFTN97
KM684000BLGI-7T
TC7S08F
BA6285FP-E2
Q406
Q407
Q408
Q411
8-729-900-53
8-729-900-53
8-729-920-82
8-729-900-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EK
DTC114EK
2SB1188-QR
DTC114EK
< IC LINK >
1-533-674-11 LINK, CHIP IC (ICP-S0.5) 0.5A
< TRANSISTOR >
– 107 –
MAIN
Ref. No.
Part No.
Description
Q415
Q416
Q417
Q601
Q603
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
8-729-026-49
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q605
Q702
Q703
Q721
Q722
8-729-900-53
8-729-901-00
8-729-120-28
8-729-921-25
8-729-021-94
Q771
Q781
Q791
Q801
Q802
Q803
Q804
Q805
Q900
Remark
Part No.
Description
R300
R301
R302
R309
R310
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
1K
1K
1K
100
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
TRANSISTOR DTC114EK
TRANSISTOR DTC124EK
TRANSISTOR 2SC1623-L5L6
TRANSISTOR FMC2
FET 2SK1657-T1B
R311
R312
R313
R316
R320
1-216-049-11
1-216-049-11
1-216-845-11
1-216-845-11
1-216-845-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
8-729-920-21
8-729-920-21
8-729-921-25
8-729-044-95
8-729-901-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TKH04
DTC314TKH04
FMC2
2SB1571-T1
DTC124EK
R321
R322
R323
R324
R325
1-216-845-11
1-216-845-11
1-216-097-00
1-216-833-11
1-216-113-00
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
10K
470K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/10W
8-729-904-07
8-729-904-48
8-729-904-48
8-729-028-83
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
FMG2
DTB113EK
DTB113EK
DTA124EUA-T106
R326
R328
R329
R330
R331
1-216-017-00
1-216-049-11
1-216-845-11
1-216-025-00
1-216-025-00
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
47
1K
100K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/10W
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SA1037AK-T146-R
Ref. No.
Remark
< RESISTOR >
R1
R2
R3
R4
R5
1-259-991-11
1-260-032-11
1-216-041-00
1-216-041-00
1-216-295-00
CARBON MELF
CARBON MELF
METAL CHIP
METAL CHIP
SHORT
470
1M
470
470
0
2%
2%
5%
5%
1/8W
1/8W
1/10W
1/10W
R332
R333
R334
R335
R336
1-216-041-00
1-216-097-00
1-208-806-11
1-208-806-11
1-216-097-00
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
470
100K
10K
10K
100K
5%
5%
0.50%
0.50%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R6
R7
R8
R9
R11
1-216-041-00
1-216-069-00
1-216-029-00
1-216-049-11
1-216-295-00
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
SHORT
470
6.8K
150
1K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R337
R338
R339
R340
R341
1-216-097-00
1-216-025-00
1-216-025-00
1-216-049-11
1-216-049-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
100
100
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R12
R13
R14
R15
R16
1-208-399-61
1-208-399-61
1-208-399-61
1-208-399-61
1-208-399-61
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
27
27
27
27
27
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R342
R343
R344
R345
R346
1-216-049-11
1-216-049-11
1-216-049-11
1-216-049-11
1-216-049-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R17
R18
R19
R21
R22
1-208-399-61
1-208-399-61
1-208-399-61
1-259-997-11
1-259-995-11
RES,CHIP
RES,CHIP
RES,CHIP
CARBON MELF
CARBON MELF
27
27
27
1.5K
1K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R347
R348
R349
R350
R351
1-216-025-00
1-216-081-00
1-216-081-00
1-216-089-00
1-216-073-00
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
100
22K
22K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R23
R25
R26
R27
R28
1-259-995-11
1-259-997-11
1-259-995-11
1-259-995-11
1-208-399-61
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
RES,CHIP
1K
1.5K
1K
1K
27
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R352
R353
R354
R355
R356
1-216-025-00
1-216-025-00
1-216-097-00
1-216-097-00
1-208-806-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100
100
100K
100K
10K
5%
5%
5%
5%
0.50%
1/10W
1/10W
1/10W
1/10W
1/10W
R29
R30
R31
R32
R33
1-208-399-61
1-216-295-00
1-216-065-00
1-260-005-11
1-260-016-11
RES,CHIP
SHORT
RES,CHIP
CARBON MELF
CARBON MELF
27
0
4.7K
5.6K
47K
2%
1/8W
5%
2%
2%
1/10W
1/8W
1/8W
R357
R358
R359
R360
R361
1-216-073-00
1-216-808-11
1-216-845-11
1-216-097-00
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
10K
82
100K
100K
2.2K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/10W
1/10W
R34
R35
5.6K
47K
2%
2%
1/8W
1/8W
R362
R363
R364
1-216-057-00 METAL CHIP
1-216-025-00 RES,CHIP
1-216-049-11 RES,CHIP
2.2K
100
1K
5%
5%
5%
1/10W
1/10W
1/10W
– 108 –
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R366
R371
R372
R373
R375
1-216-037-00
1-216-049-11
1-216-049-11
1-216-023-00
1-216-097-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
330
1K
1K
82
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R520
R521
R522
R523
R601
1-216-295-00
1-216-845-11
1-216-817-11
1-216-097-00
1-216-025-00
SHORT
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
0
100K
470
100K
100
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
R376
R377
R400
R401
R402
1-216-845-11
1-216-097-00
1-216-073-00
1-216-057-00
1-216-057-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
10K
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R602
R603
R606
R607
R608
1-216-033-00
1-216-097-00
1-216-097-00
1-216-073-00
1-216-081-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
220
100K
100K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R403
R404
R405
R406
R407
1-216-057-00
1-216-077-00
1-216-041-00
1-216-041-00
1-216-097-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
2.2K
15K
470
470
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R609
R610
R611
R612
R701
1-216-103-00
1-216-073-00
1-217-671-11
1-216-097-00
1-216-295-00
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
SHORT
180K
10K
1
100K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R408
R409
R410
R411
R412
1-216-073-00
1-216-073-00
1-216-073-00
1-216-073-00
1-216-089-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
10K
10K
10K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R702
R703
R704
R705
R706
1-216-833-11
1-216-827-11
1-216-815-11
1-216-049-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
10K
3.3K
330
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/16W
R415
R416
R417
R418
R419
1-216-097-00
1-216-085-00
1-216-097-00
1-216-097-00
1-216-073-00
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
100K
33K
100K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R707
R710
R711
R713
R721
1-216-841-11
1-216-833-11
1-216-837-11
1-216-864-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
22K
0
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R420
R421
R422
R423
R424
1-216-089-00
1-216-081-00
1-216-089-00
1-216-057-00
1-216-073-00
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
47K
22K
47K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R722
R725
R727
R732
R734
1-216-057-00
1-216-073-00
1-216-821-11
1-216-073-00
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
1K
10K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/16W
R425
R426
R427
R428
R429
1-216-081-00
1-216-089-00
1-216-089-00
1-216-057-00
1-216-073-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
22K
47K
47K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R735
R736
R761
R763
R771
1-216-817-11
1-216-817-11
1-216-296-00
1-216-296-00
1-216-212-00
METAL CHIP
METAL CHIP
SHORT
SHORT
RES,CHIP
470
470
0
0
3.9K
5%
5%
1/16W
1/16W
2%
1/8W
(US)
R430
R431
R432
R433
R500
1-216-073-00
1-216-097-00
1-216-057-00
1-216-057-00
1-216-097-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
10K
100K
2.2K
2.2K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R771
1-216-216-00 RES,CHIP
5.6K
2%
1/8W
R772
1-216-208-00 RES,CHIP
2.7K
2%
1/8W
R772
1-216-210-00 RES,CHIP
3.3K
2%
(E)
1/8W
(US)
R773
R775
1-216-296-00 SHORT
1-216-246-00 RES,CHIP
0
100K
2%
1/8W
R776
1-208-476-11 RES,CHIP
390
2%
1/8W
R776
1-208-478-11 RES,CHIP
470
2%
R777
R781
1-208-486-61 RES,CHIP
1-216-212-00 RES,CHIP
1K
3.9K
2%
2%
R781
1-216-216-00 RES,CHIP
5.6K
2%
R501
R503
R504
R506
R508
1-216-097-00
1-216-097-00
1-216-097-00
1-216-049-11
1-216-097-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
100K
100K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R509
R510
R511
R512
R515
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
1-216-295-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
SHORT
100K
100K
100K
100K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R517
R518
R519
1-216-041-00 METAL CHIP
1-216-041-00 METAL CHIP
1-216-049-11 RES,CHIP
470
470
1K
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
Remark
(E)
– 109 –
(E)
1/8W
(US)
1/8W
1/8W
(US)
1/8W
(E)
MAIN
Ref. No.
SENSOR
Part No.
SERVO
Description
Remark
R782
1-216-208-00 RES,CHIP
2.7K
2%
1/8W
R782
1-216-210-00 RES,CHIP
3.3K
2%
(E)
1/8W
(US)
R783
R785
R786
1-216-296-00 SHORT
1-216-246-00 RES,CHIP
1-208-476-11 RES,CHIP
0
100K
390
2%
2%
Ref. No.
RB514
RB515
Part No.
Description
Remark
1-216-182-00 RES, CHIP NETWORK 220 (3216)
1-216-182-00 RES, CHIP NETWORK 220 (3216)
< THERMISTOR (POSITIVE) >
1/8W
1/8W
TH401
TH402
1-809-148-11 THERMISTOR, POSITIVE
1-809-148-11 THERMISTOR, POSITIVE
(E)
< TUNER >
R786
1-208-478-11 RES,CHIP
470
2%
1/8W
(US)
1/8W
R787
R791
R792
R794
1-208-486-61
1-216-295-00
1-216-295-00
1-216-846-11
RES,CHIP
SHORT
SHORT
METAL CHIP
1K
0
0
120K
2%
5%
1/16W
(E)
R794
R801
R802
R803
R804
1-216-864-11
1-216-073-00
1-216-057-00
1-216-057-00
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
10K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R805
R806
R824
R825
R851
1-216-057-00
1-216-845-11
1-216-864-11
1-216-845-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
0
100K
12K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R852
R853
R854
R855
R856
1-216-833-11
1-216-813-11
1-216-839-11
1-216-810-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
220
33K
120
12K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R857
R858
R893
R894
R895
1-216-831-11
1-216-095-00
1-216-097-00
1-216-065-00
1-216-057-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
6.8K
82K
100K
4.7K
2.2K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R896
R897
R999
1-216-295-00 SHORT
1-216-295-00 SHORT
1-216-864-11 METAL CHIP
TU701
A-3282-045-A TUNER UNIT (TUX-012(E))
< VIBRATOR >
X1
1-767-338-11 VIBRATOR, CRYSTAL (11.2896MHz)
X300
1-781-002-11 VIBRATOR, CERAMIC (3.68MHz)
X301
1-579-886-21 VIBRATOR, CRYSTAL (32.768kHz)
X500
1-767-426-21 VIBRATOR, CERAMIC (14.74MHz)
X721
1-567-848-11 VIBRATOR, CRYSTAL (7.2MHz)
*************************************************************
1-668-190-11 SENSOR BOARD
**************
*
< CAPACITOR >
C621
0.1uF
10%
50V
< CONNECTOR >
CN620
* CN621
1-770-626-21 PIN, CONNECTOR 9P
1-691-741-21 PIN, CONNECTOR (PC BOARD) 2P
< RESISTOR >
R620
R621
R622
R623
1-216-097-00
1-216-097-00
1-216-097-00
1-216-097-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
100K
100K
100K
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< SWITCH >
0
0
0
5%
< NETWORK RESISTOR >
RB300
RB501
RB502
RB503
RB504
1-233-412-11
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
1.0K
220
220
220
220
(3216)
(3216)
(3216)
(3216)
(3216)
RB505
RB506
RB507
RB508
RB509
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
220
220
220
220
220
(3216)
(3216)
(3216)
(3216)
(3216)
RB510
RB511
RB512
RB513
1-216-182-00
1-216-182-00
1-216-182-00
1-216-182-00
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
RES, CHIP NETWORK
220
220
220
220
(3216)
(3216)
(3216)
(3216)
1/16W
S620
1-572-688-11 SWITCH, PUSH (1 KEY) (OPEN END)
S621
1-572-688-11 SWITCH, PUSH (1 KEY) (CLOSE END)
S622
1-572-688-11 SWITCH, PUSH (1 KEY) (10 DEG)
S623
1-572-688-11 SWITCH, PUSH (1 KEY) (20 DEG)
S630
1-692-431-21 SWITCH, TACTILE (RESET)
*************************************************************
A-3313-381-A SERVO BOARD, COMPLETE
**********************
*
< CAPACITOR >
C1
C2
C3
C4
C101
1-113-642-11
1-115-581-11
1-164-004-11
1-110-456-11
1-164-004-11
TANTAL. CHIP
TANTAL. CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47uF
100uF
0.1uF
47uF
0.1uF
20%
20%
10%
20%
10%
10V
16V
25V
16V
25V
C102
C105
C106
1-115-581-11 TANTAL. CHIP
1-115-581-11 TANTAL. CHIP
100uF
100uF
0.1uF
20%
20%
10%
16V
16V
25V
– 110 –
SERVO
Ref. No.
Part No.
Description
Part No.
Description
C107
C108
C109
C110
C111
1-115-581-11
1-164-004-11
1-115-581-11
1-163-251-11
1-163-005-11
TANTAL. CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
100uF
100PF
470PF
20%
10%
20%
5%
10%
Remark
16V
25V
16V
50V
50V
IC2
IC4
IC5
IC6
IC7
8-752-374-12
8-759-427-15
8-752-889-54
8-759-823-87
8-759-370-18
IC
IC
IC
IC
IC
C112
C113
C203
C204
C205
1-164-489-11
1-163-005-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
470PF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
50V
25V
25V
25V
IC501
IC551
IC601
8-752-378-67 IC CXD2548R
8-759-428-57 IC LC89170M-TLM
8-759-335-52 IC BA6195FP-YT2
C206
C207
C208
C209
C301
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
L103
L501
L503
C303
C304
C305
C306
C307
1-164-336-11
1-164-004-11
1-163-037-11
1-163-037-11
1-163-133-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.33uF
0.1uF
0.022uF
0.022uF
470PF
10%
10%
10%
5%
25V
25V
25V
25V
50V
Q1
Q2
Q3
Q4
Q5
C308
C309
C310
C311
C312
1-163-133-00
1-104-760-11
1-163-133-00
1-163-133-00
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.047uF
470PF
470PF
0.001uF
5%
10%
5%
5%
10%
50V
50V
50V
50V
50V
C313
C501
C502
C503
C504
1-163-259-11
1-164-004-11
1-135-145-11
1-163-021-11
1-163-251-11
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
0.1uF
0.47uF
0.01uF
100PF
5%
10%
10%
10%
5%
50V
25V
35V
50V
50V
C505
C506
C507
C508
C509
1-164-182-11
1-164-004-11
1-163-011-11
1-104-760-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0033uF
0.1uF
0.0015uF
0.047uF
0.1uF
10%
10%
10%
10%
10%
50V
25V
50V
50V
25V
C510
C511
C513
C514
C527
1-164-004-11
1-163-021-11
1-164-004-11
1-113-642-11
1-113-642-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
TANTAL. CHIP
0.1uF
0.01uF
0.1uF
47uF
47uF
10%
10%
10%
20%
20%
25V
50V
25V
10V
10V
C551
C601
C603
C605
1-164-004-11
1-164-004-11
1-164-004-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
25V
25V
25V
25V
< CONNECTOR >
CN1
CN2
CN4
CN5
1-764-616-12
1-766-491-11
1-770-347-21
1-569-775-21
HOUSING, CONNECTOR (PC BOARD) 30P
CONNECTOR, FPC 17P
CONNECTOR, FPC 6P
PIN, CONNECTOR 5P
< IC >
IC1
8-752-069-29 IC CXA1791N
Ref. No.
Remark
CXD2522R-T6
MB814400C-70PFTN
CXP84640-011Q
LB1638M
BA6797FP-E2
< COIL >
1-412-060-11 INDUCTOR CHIP 22uH
< TRANSISTOR >
8-729-901-05
8-729-011-95
8-729-141-48
8-729-901-00
8-729-901-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124EK
RN-2426
2SB624-BV345
DTC124EK
DTC124EK
< RESISTOR >
R101
R102
R103
R104
R105
1-216-295-00
1-216-081-00
1-216-081-00
1-216-103-00
1-216-103-00
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22K
22K
180K
180K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R106
R108
R109
R110
R111
1-216-001-00
1-216-051-00
1-216-057-00
1-216-057-00
1-216-065-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
10
1.2K
2.2K
2.2K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R112
R113
R114
R115
R140
1-216-065-00
1-216-073-00
1-216-097-00
1-216-073-00
1-216-073-00
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
4.7K
10K
100K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R141
R142
R143
R203
R209
1-216-081-00
1-216-089-00
1-216-093-00
1-216-097-00
1-216-089-00
METAL CHIP
RES,CHIP
METAL CHIP
RES,CHIP
RES,CHIP
22K
47K
68K
100K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R210
R213
R214
R217
R218
1-216-841-11
1-216-049-11
1-216-864-11
1-216-081-00
1-216-089-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
RES,CHIP
47K
1K
0
22K
47K
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/10W
1/10W
R219
R220
R222
R223
R224
1-216-097-00
1-216-097-00
1-216-845-11
1-216-841-11
1-216-841-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R301
1-216-025-00 RES,CHIP
100
5%
1/10W
– 111 –
SERVO
Ref. No.
SUB
Part No.
Description
R302
R303
R304
R305
R306
1-216-037-00
1-216-308-00
1-216-683-11
1-216-675-11
1-216-683-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
4.7
22K
10K
22K
5%
5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
Ref. No.
R307
R308
R309
R310
R311
1-216-675-11
1-216-683-11
1-216-675-11
1-216-683-11
1-216-675-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
22K
10K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R312
R313
R314
R315
R316
1-216-085-00
1-216-089-00
1-216-103-00
1-216-085-00
1-216-683-11
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
47K
180K
33K
22K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R317
R318
R319
R320
R333
1-216-675-11
1-216-683-11
1-216-675-11
1-216-097-00
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
10K
22K
10K
100K
0
0.5%
0.5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/16W
R334
R398
R399
R501
R502
1-216-089-00
1-216-296-00
1-216-296-00
1-216-097-00
1-216-073-00
RES,CHIP
SHORT
SHORT
RES,CHIP
METAL CHIP
47K
0
0
100K
10K
5%
1/10W
20
21
1-783-269-11 CORD (WITH CONNECTOR) (POWER)
1-783-270-21 CORD, POWER
1-790-088-11 CORD (WITH CONNECTOR) (INVERTER)
5%
5%
1/10W
1/10W
R503
R504
R505
R506
R507
1-216-121-00
1-216-061-00
1-216-061-00
1-216-073-00
1-216-125-00
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
3.3K
3.3K
10K
1.5M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
63
69
109
110
123
1-669-127-11
1-803-056-11
1-778-182-11
1-670-154-11
1-777-246-31
FLEXIBLE SW BOARD
LIQUID CRYSTAL MODULE
SOCKET, CONNECTOR 18P
FLEXIBLE BOARD
CORD (WITH CONNECTOR) (ANT)
R508
R509
R510
R511
R519
1-216-105-00
1-216-113-00
1-216-061-00
1-216-073-00
1-216-081-00
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
470K
3.3K
10K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
257
! 260
262
F901
M901
1-659-880-11
8-848-402-02
1-659-881-11
1-532-877-11
X-3373-096-1
MOTOR FLEXIBLE BOARD
PICK-UP, OPTICAL KSS-520A/J2NP
PICK-UP FLEXIBLE BOARD
FUSE (BLADE TYPE) (AUTO FUSE) 10A
MOTOR ASSY (SPINDLE)
R524
R525
R526
R527
R528
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
1-216-296-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
220
220
220
220
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R529
R530
R531
R532
R533
1-216-073-00
1-216-295-00
1-216-065-00
1-216-829-11
1-216-065-00
METAL CHIP
SHORT
RES,CHIP
METAL CHIP
RES,CHIP
10K
0
4.7K
4.7K
4.7K
5%
1/10W
5%
5%
5%
1/10W
1/16W
1/10W
R551
R552
R553
R554
R555
1-216-089-00
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R601
R602
R603
1-216-081-00 METAL CHIP
1-216-295-00 SHORT
1-216-085-00 METAL CHIP
22K
0
33K
5%
1/10W
5%
1/10W
R604
R605
Part No.
Description
Remark
1-216-097-00 RES,CHIP
1-216-081-00 METAL CHIP
100K
22K
5%
5%
1/10W
1/10W
< VIBRATOR >
X1
1-760-365-11 VIBRATOR, CERAMIC (10MHz)
*************************************************************
1-659-834-11 SUB BOARD
**********
*
< CONNECTOR >
CN1
1-770-347-21 CONNECTOR, FPC 6P
*************************************************************
MISCELLANEOUS
***************
3
17
18
M902
A-3301-107-A MOTOR ASSY, SLED (SLED)
M903
A-3291-676-A MOTOR SUB ASSY, LOADING (LOADING)
M904
A-3301-552-A MOTOR SUB ASSY (PANEL)
*************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
1-473-967-31
1-475-642-31
3-012-266-01
3-339-410-11
3-862-328-11
COMMANDER, ROTARY (RM-X90)
REMOTE COMMANDER (RM-X9)
LID, BATTERY CASE (for RM-X9)
COVER (2), PIN JACK
MANUAL, INSTRUCTION (ENGLISH) (US)
3-862-328-21 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
CHINESE) (E)
3-864-350-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH)
(US)
3-864-350-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,CHINESE) (E)
3-864-494-11 MANUAL, FITTING INSTRUCTION (ENGLISH,
SPANISH,CHINESE) (for RM-X9) (E)
X-3375-799-1 CASE ASSY (90)
*************************************************************
specified.
– 112 –
Ref. No.
Part No.
Description
Remark
Ref. No.
#1
#2
#3
#4
#5
7-685-851-04
7-685-792-09
7-685-105-19
7-685-790-09
7-621-772-20
SCREW +BVTT 2X4 (S)
SCREW +PTT 2.6X6 (S)
SCREW +P 2X8 TYPE2 NON-SLIT
SCREW +PTT 2.6X4 (S)
SCREW +B 2X5
#6
#7
#8
#9
#10
7-627-553-28
7-624-102-04
7-621-772-10
7-627-553-68
7-685-146-11
SCREW, PRECISION +P 2X2.5
STOP RING 1.5, TYPE -E
SCREW +B 2X4
SCREW, PRECISION +P 2X6
SCREW +P 3X8 TYPE2 NON-SLIT
#11
#12
#13
#14
#15
7-621-775-08
7-628-253-15
7-627-553-37
7-628-253-00
7-627-553-17
SCREW +B 2.6X3
SCREW +PS 2X5
SCREW, PRECISION +P 2X3 TYPE3
SCREW +PS 2X4
SCREW, PRECISION +P 2X2 TYPE3
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
***************
HARDWARE LIST
***************
#16
7-627-000-00 SCREW, PRECISION +P 1.7X2.2 TYPE3
#17
7-627-850-28 SCREW, PRECISION +P 1.4X3
#18
7-621-710-26 SET-SCREW, SLOT 2X3 FLAT POINT
*************************************************************
301
302
303
304
305
3-009-613-21
3-025-812-01
3-027-138-01
3-934-325-01
3-924-961-01
FRAME
COLLAR (90)
SPRING, FITTING
SCREW, +K (5X8) TAPPING
SUPPORT (ND), FITTING (US)
306
307
308
309
310
X-3368-725-1
7-682-560-04
X-3366-405-1
3-386-828-01
3-349-410-01
SCREW ASSY, FITTING (US)
SCREW +P 4X6 (US)
SCREW ASSY (EXP), FITTING (E)
SCREW, FITTING (E)
BUSHING (E)
311
312
313
314
315
7-685-248-14
3-012-265-01
3-937-921-01
1-783-269-11
3-028-789-01
SCREW +KTP 3X12 TYPE2 NON-SLIT
HOLDER
TAPE (HOLDER)
CORD (WITH CONNECTOR) (POWER)
COVER (LIGHT)
316
7-682-546-09 SCREW +B 3X5
301
302
306
307
305
311
315
– 113 –
303
312
316
304
308
309
313
314
310
CDX-C90
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.
Ver.
1.1
1.0
Date
2001. 08
1998. 07
Description of Revision
The CORRECTION-1, 2 are included into Ver 1.1
New
– 116 –

CDX-C90 -- Service Manual

Transcription

Similar documents

Alesis MultiMix 16 USB (XU7) Service Manual

SERVICE MANUAL

VSX-815-S VSX-915-K

Parts List - Santa Clara Systems

SERVICE MANUAL

D-CJ500/CJ501/CJ506CK - Vintage

CD5000 - SManuals.ru

Aiwa CDC-R504MP, CDC-X504MP Service manual. www.s

SERVICE Manual

Chassis 16.1 - Electronica.ro

SERVICE MANUAL

SERVICE MANUAL

STR-DA4ES/DA7ES/VA333ES

CDX-M620 - Electronica.ro

pk-46 board

Service Manual - Honda Goldwing

(800) 590-4133 [email protected]