MODEL 75A TRACTOR SHOVEL PARTS MANUAL

Transcription

MODEL
75A
TRACTOR SHOVEL
PARTS MANUAL
No. 1188
Record Your Machine Serial Number
and Engine Model Specification and
Serial Number Here
Machine Serial Engine Model Engine Serial CLARK
EQUIPMENT
CLgIRK EQUIPMENT COMPANY
Construction Machinery Division
BENTON HARBOR, MICHIGAN, U.S.A.
MICHIGAIll
/
\
*'
C
CLARK
EQUIPMENT
CONSTRUCTION MACHINERY DIVISION
MICHIG1111
WHEN ORDERING REPAIR PARTS
Order through your nearest Clark Distributor, for THE MICHIGAN LINE.
Always give serial number of machine.
Furnish: Quantity, Part Number and Description.
WHEN PARTS ARE RECEIVED
Check immediately for quantity, correctness and condition.
Advise your Michigan Distributor of any error.
Claims for damages, during shipment, should be made to the carrier
immediately.
INDEX
MODEL 75 SERIES
Page
Page
A
2
Cap, Distributor 2
Carburetor 2
Carburetor Repair Kit
Carrier Assembly and Bucket 11
Cartridge Kit — Lube Oil Filter 4
Cartridge Kit — Primary Filter 4
4
Cartridge Kit — Secondary Filter Cartridge Kit — Trans and Torque Converter 62, 63
Coil, Ignition
2
Control Cover Parts — Transmission 31
Control Valve Assembly 89
Converter Charging Hydraulic Pump 82
Counterweight, Grille and Body Panels 9
Cutting Edge Replacement Kit — Bucket 11
Cylinder Assembly — Boom 91
Cylinder Assembly — Bucket 92
Accelerator Pedal and Linkage — DIESEL 17
Accelerator Pedal and Linkage — GAS
18
Adaptor, Steering Booster — MODEL 75B
77, 78
Adaptor, Steering Booster — MODEL 75R
79, 80
Air Cleaner and Attaching Parts
15
Armature — Generator 1
Armature — Starter 3
Axle Assembly — F.D. — MODEL 75A and 75B 41
Axle Assembly — F.S. — MODEL 75R 43
Axle Assembly — R.D. — MODEL 75R 41, 53
Axe Assembly — R.D.S. — MODEL 75A 45, 47
Axle Assembly — R.S. — MODEL 75B 49, 51
B
Back Up Lamp Assembly 102
Battery, Holder, Wiring and Parts 102
Body Panels, Counterweight and Grille 9
Boom and Guide Bar Assembly 10
Boom Cylinder Assembly 91
Boom Pipe Assembly — R.H. 10
Boom Pipe Assembly — L.H. 10
Booster Pump — Steering 81, 82
Brake Assembly — Front 93
Brake Assembly — Rear 94
Brake Controls — MODEL 75A
95, 98
Brake Controls — MODEL 75B and 75R 98
Brake Cylinder Assembly — Front 93
Brake Cylinder Assembly — Rear 94
Brake Lines and Fittings -- MODEL 75A 97, 98
Brake Lines and Fittings — MODEL 75B and 75R 98
Brush — Generator Brush — Starter 3
Bucket and Boom Hydraulic Pump 84, 85
Bucket and Boom Hydraulic System 86, 87
Bucket and Carrier Assembly 11
Bucket Cylinder Assembly 92
Bucket Indicator 12
C
Cables, Battery Cables, Ignition PM-1188
D
Differential and Carrier Assembly Distributor and Parts Drag Link Assembly 57
2
74
E
Engine Accessories Engine Assembly
Engine Support Parts Engine Temperature Sending Unit Ether Start Panel Assembly 1, 2, 3, 4
1
1
1
107
F
Filter, Lube Oil 3
4
Filter, Primary Fuel 4
Filter, Secondary Fuel 4
Filter, Third Stage Fuel Filter, Trans. and Torque Converter Oil 62, 63
105
Floorboards Frame Assembly — MODEL 75A 5
6
Frame Assembly — MODEL 75B 7
Frame Assembly — MODEL 75R Front Brake Assembly 93
102Fuel Injection Pump 3
2Fuel Injector 3
[A]
CUIRK
EQUIPMENT
Fuel Lines - DIESEL
Fuel Lines - GAS Fuel Pump Assembly Fuel Pump Repair Kit Fuel Tank Assembly Fuel Tank Mounting Kit Page
Page
19, 21
22
2
3
105
105
Pump, Fuel Injection 3
Pump, Hydraulic - Bucket and Boom 84, 85
Pump, Hydraulic - Converter Charging 82
Pump, Hydraulic - Steering Booster 81, 82
Push Rod Assembly - Steering Booster - Axle 72
R
Radiator and Parts 13
Rear Brake Assembly 94
Regulator, Voltage 2
Repair Kit, Carburetor 2
Repair Kit, Fuel Pump 3
Repair Kit, Master Cylinder 95, 98
Repair Kit, Steering Booster 67, 69, 71
Repair Kit, Wheel Cylinder - Front 93
Repair Kit, Wheel Cylinder - Rear 94
Reservoir, Hydraulic Oil 83
Ring Gear and Pinion Set 57
2
Gasket Kit, Carburetor 101
Gauges, Instrument Panel 58
Gear Shift Levers and Linkage 1
Generator Armature 1
Generator Assembly 1
Generator Brush Glow Plugs ____
3
9
Grille, Counterweight and Body Panels 10
Guide Bar and Boom Assembly H
S
102
Head Lamp Assembly 9
Hood Assembly Horn, Floorboard and Fuel Tank Assembly 105
1
Hourmeter and Parts 54
Hub Assembly - MODEL 75B and 75R 83
Hydraulic Oil Reservoir and Parts Hydraulic Pump - Bucket and Boom 84, 85
82
Hydraulic Pump - Converter Charging Hydraulic Pump - Steering Booster 81, 82
Hydraulic System - Bucket and Boom 86, 87
Hydraulic System - Steering - MODEL 75A 75, 76
Hydraulic System - Steering - MODEL 75B 77, 78
Hydraulic System - Steering - MODEL 75R 79, 80
Hydraulic System - Trans. and Torque
62, 64
Converter Ignition Cables Ignition Coil Injector, Fuel Instrument Panel Assembly and Parts Secondary Fuel Filter 4
Secondary Fuel Filter Cartridge Kit 4
Sender Unit, Engine Temperature
1
Sender Unit, Torque Converter Temperature 62, 63
Starter Brush 3
Starter Armature 3
Starter Assembly 3
Starter Pedal and Linkage - Mechanical 106
Start Panel Assembly -- Ether 107
Steering Booster AdaptorMODEL 75B 77, 78
MODEL 75R 79, 80
Steering Booster Adaptor -MODEL
Steering Booster Assembly 67, 69, 71
Steering Booster Hydraulic Pump 81, 82
Steering Booster Push Rod Assembly 72
Steering Gear Assembly and Parts
65
Steering Hydraulic System- MODEL 75A 75, 76
Steering Hydraulic System - MODEL 75B 77, 78
Steering Hydraulic System - MODEL 75R 79, 80
Steering Wheel 65
2
2
3
101
L
Lights and Mountings Lube Oil Filter Assembly Lube Oil Filter Cartridge Kit 102
Tail Lamp Assembly Third Stage Fuel Filter 4
Tie Rod End Assembly 73
Tire and Wheel Assembly 103
102
Tools Torque Converter Assembly ____33, 34, 35, 37, 38, 39
Torque Converter Mounting Parts 35, 39
Torque Converter Temperature Sender Unit 62, 63
Trans. and Torque Converter Hydraulic System 62, 63
Trans. Control Levers and Linkage - MODEL 75A __ 59
Trans. Control Levers and Linkage MODEL 75B and 75R 60
Transmission Assembly - MODEL 75A 25, 26, 27
Transmission Assembly - MODEL 75B and 75R 28
Transmission Control Cover Parts 31
Transmission Mounting Parts 27
102
3
M
Main Hydraulic Pump 84, 85
Master Cylinder - Brake - Model 75A 95, 98
Master Cylinder - Brake - Model 75B and 75R ____ 98
Mechanical Starter Pedal and Linkage 106
15
Muffler and Parts 0
Oil Filter Cartridge Kit - Lube Oil Filter - Lube Oil Reservoir, Hydraulic 4
3
83
P.
Parking Brake Controls Planet Spider Assembly Point Set, Distributor Primary Fuel Filter Primary Fuel Filter Cartridge Kit Propeller Shaft Assemblies Pump, Fuel PM-1188 mICHlcnn
96
55
2
4
4
61
2
V
[
B]
Voltage Regulator Valve Assembly - Control 2
89
Wheel Assembly and Tire Wheel, Steering 103
65
CLARK
MICHIG1111
EQUIPMENT
ENGINE ACCESSORIES
ENGINE ASSEMBLY
Part
Item
No.
No.
All orders for engine assembly or components thereof
should be placed with the nearest Waukesha Motor Co.
18
distributor or dealer. Always give model, specifications
(Continued)
Description
No.
Req'd.
Armature, Generator 1
940588 For Serial:
and serial number of your engine. This data will be
75A-8123 & thereafter
found stamped on name plate attached to side of engine.
75B-6123 thru 6200
75R-7123 & thereafter
ENGINE SUPPORT PARTS
1
75B-6201 & thereafter
No.
Part
No.
Item
No.
871535 Effective with Serial:
Description 550697
Req'd.
19
Brush, Generator Support Assembly — L. H. 1
940136 For Serial:
2
551777
Support Assembly — R. H 1
3
1C-824
Bolt, Support to Flywheel Hsg... .
8
75B — 6123 thru 6200
4
4E-08
Lkwshr, Support to Flywheel Hsg..
8
5
2C-832
Bolt, Support to Frame 4
6
21D-08
Nut, Support to Frame 4
7
550698
Pad, Support to Frame 2
8
619029
Washer, Trunnion to Frame 2
9
2C-832
Bolt, Trunnion to Frame 2
10
21D-08
Nut, Trunnion to Frame 2
20 619052 Fan, Gen. — For 940318 Gen. Only
21 630506 Baffle, Gen. — For 940318 Gen.
Only 22
ENGINE ACCESSORIES
1
Pulley, Generator 940134 For Serial:
11
551323
Sending Unit, Engine Temperature.
1
12
550832
Sending Unit, Oil Pressure 1
13
940323
Meter, Hour 1
14
953130
Gasket, Hourmeter 1
15
552837
Screw, Hourmeter Mtg . 4
16
552839
Washer,Hourmeter Mtg.. .....
4
Generator Assembly 1
75B-6123 thru 6200
17
940318
24 940714 Washer, Pulley 1
1
26 957243 Strap, Gen. Adjusting 1
27 1C-512Bolt, Adj. Strap 2
28 619019 Washer, Adj. Strap 1
29 4E-05Lkwshr, Adj. Strap 2
Effective with Serial:
30 1C-516Bolt, Rear Mounting 1
31 4E-05Lkwshr, Rear Mounting 1
75B-6123 thru 6200
PM 1188
1
25 850311 Nut, Pulley
For Serial:
75A-8123 &•thereafter
664858
23 6J-405 Key, Pulley [1]
CLeiRK
EQUIPMENT
(Continued)
ENGINE ACCESSORIES
ItemPart
No.No.
ItemPart
No.No.
No.
Req'd.
Description
No.
Description
Req'd.
32
2C-524
Bolt, Front Mounting
1
56
850091
Rotor, Distributor 1
33
552885
Spacer, Front Mounting
1
57
853586
Housing, Cover (Inc. 58 & 59) 1
34
2D-05
Nut, Front Mounting
1
58
853599
Gasket 1
35
4E-05
Lkwshr, Front Mounting
1
59
858150
Seal, Felt 1
60
850085
Condenser 1
61
552856
Ignition Cable Kit (Inc. 62 thru 68)
1
62
552844
Cable — 1 & 6 Cyl.
2
63
552845
Cable — 2 & 5 Cyl.
2
64
552846
Cable — 3 Cyl.
1
65
552847
Cable — 4 Cyl.
1
66
652772
Cable,Distributor to Coil 1
67
610097
Nipple,Distributor
7
68
610098
Nipple, Coil
1
69
940104
Coil,Ignition 1
70
2C-510
Bolt, Coil to Bracket 2
71
2D-05
Nut, Coil to Bracket 2
72
4E-05
Lkwshr, Coil to Bracket 2
550850
36
Wiring Harness, Gen. to Volt Reg.. 1
Voltage Regulator 37
940105
For Serial:
75B-6123 thru 6200
941520
1
38
550862
Bracket, Regulator Mtg.
39
2C-620
Bolt, Bracket to Frame
40
2D-06
Nut, Bracket to Frame 41
4E-06
Lkwshr, Bracket to Frame 2
42
2C-412
Bolt, Reg. to Bracket
43
2D-04
Nut, Reg. to Bracket 3
73
940177
Carburetor 44
4E-04
Lkwshr, Reg. to Bracket 3
74
952797
Gasket, Carb. to Manifold 1
75
552825
Stud, Carb. to Manifold 2
45
551530
Magnetic Switch (Solenoid)
1
76
2D-05
Nut, Carb. to Manifold 2
46
2C-414
Bolt, Switch Mtg.
2
77
4E-05
Lkwshr, Carb. to Manifold 2
47
2D-04
Nut, Switch Mtg. 2
78
940178 *RepairKit, Carburetor 48
4E-04
Lkwshr, Switch Mtg. 2
79
940179 *Gasket, Kit, Carburetor 80
853227
Main Jet, Adjustable 1
81
552826
Fuel Line Assy., Pump to Carb. . . 1
82
552838
Clip,FuelLine 1
83
1C-410
Bolt,FuelLineClip. . ....... . . .
1
84
4E-04
Lkwshr, Fuel Line Clip 1
85
62F-4
Elbow, Fuel Line to Carb. & Pump .
2
86
941591
Fuel Pump Assy. (Inc. 87) 1
2
2
3
ENGINE ACCESSORIES — GAS MODEL ONLY
49 940331Distributor
1
50 953129 Gasket, Distributor
1
51 552842 Clamp, Distributor 2
52 1C-618Bolt, Clamp 2
53 4E-06Lkwshr, Clamp 2
54 857852 Cap, Distributor
1
55 940026 Point Set, Distributor
1
— As Required
PM 1188
[2]
CUIRK
EQUIPMENT
MICHIGAll
ENGINE ACCESSORIES (Continued)
ItemPart
No.No.
Description
Item
No.
No.
Req'd.
No.
941943
1
87 952721 Gasket, Fuel Pump Part
Description
No.
Req'd.
1
75A-9639D & thereafter except 9889D
89 1C-516 Bolt, Pump Mtg. 2
75B-6181D & thereafter.
90 952779 Washer, Copper 2
75R-7151D & thereafter
88 620558 Elbow
91 941945 *Repair Kit, Fuel Pump (Inc. 92).
104
92 941944 *Repair Kit, Diaphragm
Injector, Fuel 953127
75A-8123D thru 9638D & 9889D
1
93 553348 *Starter Assembly ForSerial:
75B-6123D thru 6180D
* #940137 Starter Assy used on Serial 8123 thru 9082.
75R-7123D thru 7150D
Use item 93 for replacement, removing #552884
954601
Spacer Item 94.
94 552884 Spacer, Starter -- See Note Above . 1
75B-6181D & thereafter
95 957361 Stud, Mtg. — Use only with
3
#940137 Starter 105
552814
Glow Plugs 6
106
953103
Gasket, Glow Plugs 6
107
553139
Harness, Glow Plugs 1
108
552941
Bracket, Glow Plug Harness 1
109
2G-1210 Screw, Bracket Attaching 1
110
14D-12
Nut, Bracket Attaching 1
111
2E-04
Lkwshr, Bracket Attaching 1
101 553349 Housing, Drive—Note—when using
112
648382
Starter Assembly 1
with #940137 Starter, Remove
113
552884
Spacer, Mounting 1
114
1C-628
Bolt, Starter Mtg. 3
115
4E-06
Lkwshr, Starter Mtg. 3
116
864539
Armature, Starter 1
117
864519
Switch, Solenoid 1
118
864548
Drive Assy. 1
119
864559
Housing, Drive 1
75A-8123D thru 9638D & 9889D
120
864525
Brush 4
75B-6123D thru 6180D
121
940582
Lube Oil Filter Assy. 1
75R-7123D thru 7150D
122
956814
Gasket, Bracket to Crankcase 1
96 2D-06Nut, Mtg. — Use only with
3
#940137 Starter 97 4E-06 Lkwshr, Mtg. 3
98 1C-620 Bolt, Mounting 3
99 850813 Armature, Starter 1
100 852135 Drive Assembly Spacer Item 94
1
1
102 940139 Brush, Starter ENGINE ACCESSORIES — DIESEL ONLY
103
Pump, Fuel Injection
1
940897 For Serial:
— As Required
PM 1188
[3
]
CUIRK
EQUIPMENT
MICHIGM1
ENGINE ACCESSORIES (Continued)
Item
No.
Part
No.
Description No.
Req'd.
123
940034
Cartridge Kit, Lube Oil Filter 2
124
957299
Gasket, Oil Filter Shell 1
125
551331
Fuel Filter, Primary 1
126
940107
Cartridge Kit, Primary Fuel Filter 1
Fuel Filter, Secondary 1
ItemPart
No.No.
128
Description
No.
Req'd.
Cartridge Kit, Secondary Filter.. .
940027 For Serial:
75A-8123D thru 9638D & 9889D
127
940183
75B-6123D thru 6180D
75R-7123D thru 7150D
For Serial:
75A-8123D thru 9638D & 9889D
75B-6123D thru 6180D
75R-7123D thru 7150D
553858
PM 1188
129 Fuel Filter, Third Stage Effective with Serial:
958166 For Serial:
75A-9639D & thereafter except 9889D 75A-8123D thru 9638D & 9889D
75B-6 03D thru 6180D
75R-7123D thru 7150D
[4]
CUIRK
EQUIPMENT
MICHIG1111
FRAME ASSEMBLY
MODEL 75A
Item
No.
Part
No.
1
No.
Req'd.
Frame Assembly 550000
2
3
4
5
6
Description
514265
For Serial 8123 thru 10222, 10240
& 10247 thru 10251 Effective with Serial 10223 thru
10239, 10241 thru 10246, 10252
& thereafter
550010
2D-12
550263
550010
2C-856
Bushing, Boom Pivot Tube Nut, Axle Mtg. Bolt, Axle Mtg. Bushing, Boom Cyl. Pivot Shaft...
Bolt, Cradle Pivot Pin Item
No.
1
7
8
9
10
11
12
13
14
15
16
17
18
2
16
8
2
2
—As Required
t — Not Illustrated
PM 1188
[5
l
Part
No.
Description
No.
Req'd.
15H-15
Fitting, Cradle Pivot Pin Grease..
550070
Shaft, Boom Cyl. Pivot 550069
Pin, Cradle Pivot 4E-08
Lkwshr, Cradle Pivot Pin 2D-08
Nut, Cradle Pivot Pin 550066
Bushing, Cradle Pivot Pin 550062
Drive Steer Axle Cradle Assembly.
2D-12
Nut, Axle Mtg. 550254
Bolt, Axle Mtg. 551348 *Washer, Cradle to Frame 551347 *Washer, Cradle to Frame 550253 1- Pad, Axle Mtg. 2
1
2
2
2
2
1
16
2
CU MK
MACHINERY DIVISION
CONSTRUCTION
EQUIPMENT
MICHIGEM
FRAME ASSEMBLY
MODEL 75B
Item
No.
Part
No.
Item
No.
No.
Req'd.
Frame Assembly 1
2
3
4
5
Description
550105
517076
For Serial 6123 thru 6200
Effective with Serial 6201 & thereafter
550010
2D-12
550263
550010
Bushing, Boom Pivot Tube
Nut, Drive Axle to Frame
Bolt, Drive Axle to Frame
Bushing, Boom Pivot Tube
1
6
7
8
9
2
16
8
2
9A
10
11
PM 1188
[6]
Part
No.
Description
550070
1F-848
4D-24
626561
626515
626516
10H-2
-
No.
Req'd.
Shaft, Boom Cyl. Pivot Cotter, Pivot Pin Nut, Pivot Pin Bushing & Pivot Pin Assy. (Inc. 9A
&10) Pivot Pin Extended End Silent Block I- Grease Fitting 1
2
2
2
2
2
4
CLARK
EQUIPMENT
CONSTRUCTION MACHINERY
DIVISION.
mocHOGAn
FRAME ASSEMBLY
MODEL 75R
Item
No.
Part
No.
Description
550112
517087
Frame Assembly For Serial 7123 Thru 7154
Effective with Serial 7155 & thereafter
2
550010
Bushing, Boom Pivot Tube 2
3
2C-672
Bolt, Axle Pivot Pin 2
4
11H-15
Fitting, Axle Pivot Pin Grease 2
1
PM 1188
Item
No.
No.
Req'd.
5
6
7
8
9
10
11
12
I7
]
Part
No.
550120
4E-06
2D-06
550010
550070
2D-12
550263
10H-2
Description
No.
Req'd.
Pin, Axle Pivot Lkwshr, Axle Pivot Pin Nut, Axle Pivot Pin Bushing, Boom Cyl. Pivot Pin Shaft, Boom Cyl. Pivot Nut, Axle to Frame Bolt, Axle to Frame Grease Fitting 2
2
2
2
1
16
8
4
17
0
5
70
0
z
n
z
in
711
IA
O
z
T5-258
a
C-3
GRILLE, COUNTERWEIGHT AND BODY PANEL ASSEMBLY
CI
CUIRK
EQUIPMENT
MICHIGAll
GRILLE, COUNTERWEIGHT AND BODY PANEL ASSEMBLY
ItemPart
No.No.
Description No.
Req'd.
ItemPart
No.No.
5
Hood Assembly — GAS 1
550890 For Serial:
75A — 8123 thru 10222, 10240 &
10247 thru 10251
75B — 6123 thru 6200
75R — 7123 thru 7154
514428Effective with Serial:
75A — 10223 thru 10239, 10241
thru 10246, 10252 and thereafter
75B6201 and thereafter
75R — 7155 and thereafter
6518233
7 4E-08
82C-824
92D-06
104E-06
11550635
12103376
13551835
14518233
15551835
162C-622
17 550634
17A 553744
17B 2C-616
17C 2D-06
17D 4E-06
18550833
19551544
20551539
214E-08
222C-836
23103293
Pad, Hood to Frame. . . . . ....
Lkwshr, Hood to Frame Bolt, Hood to Frame Nut, Back Rest Cushion Lkwshr, Backrest Cushion Cushion, Back Rest Nut, Hood to Frame Lock . . . • •
Washer, Hood to Frame.
Pad, Hood to Frame Washer, Hood to Frame Bolt, Hood to Frame. . .
Cushion, Seat tSeat Support Assembly tBolt, Seat Support Assembly tNut, Seat Support Assembly tLkwshr, Seat Support Assembly...
Front Shroud Ass'y. (Inc. Item 19).
Cap, Fuel Tank Bar, Bumper Lkwshr, Bumper Bar to Brace Bolt, Bumper Bar to Brace Washer, Shroud to Frame 1
2
2
2
2
2
1
2
2
2
2
2
1
1
4
4
4
1
1
2
4
4
4
31 552336Hood Catch Assembly 4
32 2G-1014 Screw, Hood Catch Assembly 8
33 12E-10Lkwshr, Hood Catch Assembly 8
34 14D-10Nut, Hood Catch Assembly 8
35 2G-1014 Screw, Bumper 4
36 551434Bumper, Hood Side Panel 4
37 616775Washer, Bumper 4
38 13E-10Lkwshr, Bumper 4
39 14D-10Nut, Bumper 4
40 2D-10 Nut, Grille 2
41 4E-10Lkwshr, Grille
2
42 2C-1052 Bolt, Grille
2
42 2D-12 Nut, Counterweight to Frame 4
44 616813Washer, Counterweight to Frame. 2
45 16C-12180 Bolt, Counterweight to Frame 2
46 16C-12224 Bolt, Counterweight to Frame 2
47 616813Washer, Counterweight to Frame. 2
48 2D-12 Nut, Counterweight to Frame 4
49 550583Counterweight 1
50 550586Drawbar Pin Assembly 1
PM 1188
No.
Req'd.
24 4E-06
Lkwshr, Shroud to Frame 4
25 2C-610
Bolt, Shroud to Frame 4
26 550893
Side Panel 2
27 103293
Washer, Side Panel 12
28 4E-06
Lkwshr, Side Panel 12
29 2C-610
Bolt, Side Panel 12
30
Hood Side Panel Assembly — R.H.. 1
550883
For Serial:
75A-8123 thru 10222, 10240 and
10247 thru 10251
75B-6123 thru 6200
75R-7123 thru 7154
514226
75A-10223 thru 10239, 10241
75B-6201 and thereafter
75R-7155 and thereafter
30A
Hood Side Panel Assembly—L.H.. . 1
550886
For Serial:
75A-8123 thru 10222, 10240 and
10247 thru 10251
75B-6123 thru 6200
75R-7123 thru 7154
75A-10223 thru 10239, 10241
75B-6201 and thereafter
75R-7155 and thereafter
1550252 Grille
1
22D-06Nut, Hood to Rear Grille 6
34E-06Lkwshr, Hood to Rear Grille 6
42C-620 Bolt, Hood to Rear Grille 6
5A Hood Assembly — DIESEL 550889 For. Serial:
75A-8123D thru 10222D, 10240D
and 10247D thru 10251D
75B-6123D thru 6200D
75R-7123D thru 7154D
75A-10223D thru 10239D,
10241D thru 10246D, 10252D
and thereafter
75B-6201 D and thereafter
75R-7123D and thereafter
Description
I9]
CLARK
EQUIPMENT
DIVISION
MICHIGAll
BOOM AND GUIDE BAR ASSEMBLY
Item
No.
1
1A
Part
No.
10H-35
11H-15
Description
No.
Req'd.
Item
No.
Grease Fitting — 1/4 -28 — For use on
28
GuideBarBosseswith1/4"
2
thread 12
Grease Fitting — 1/8 P.T. — For use on
GuideBar Bosses with 1/8Pipe
Thread Pin, Carrier to Boom 2
2C-648
Bolt,PinRetaining 2
550143
Bushing, Boom to Carrier ..... . . . .
2
15
10H-25
Fitting, Carrier to Boom Grease. . . .
2
16
550130
Boom & Pipe Assembly (Inc. 14, 16A
2
16A
550144
tBoom Pipe Assembly — R.H. 1
2
2
16B
1
2
550176 tBoom Pipe Assembly — L.H. 2C-648
Bolt, Pin Retaining 550179
Pin, Boom to Cylinder 2
&16B)
Bushing, Guide Bar to Frame Nut, Pin Retaining 4
5
4E-08
550188
Lkwshr,PinRetaining Pin, Guide Bar to Frame 6
7
2C-876
512991
Bolt,PinRetaining Guide Bar Assembly (Inc. 2 & 8). . .
2
18
19
1
8
9
550143
10H-25
Bushing, Guide Bar to Bucket Fitting, Carrier to Guide Bar Grease
2D-06
4E-06
Nut, Pin Retaining Lkwshr, PinRetaining 17
1
2
2
4E-06
Lkwshr, Pin Retaining 2
20
2D-06
Nut, Pin Retaining 2
2
21
550178
Shaft, Boom Pivot 1
2
22
2D-08
Nut, Shaft Retaining 2
2
23
24
4E-08
Lkwshr, Shaft Retaining 2
2C-876
Bolt, Shaft Retaining 2
2
PM 1188
No.
Req'd.
14
550191
2D-08
10
550207
Description
13
2
3
11
Part
No.
[
10
]
CUIRK
EQUIPMENT
DIVISION
MMMG M
BUCKET AND CARRIER ASSEMBLY
Item
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
PM 1188
Part
No.
550193
550208
2C-672
4E-06
552550
2C-648
4E-06
2D-06
550231
2C-656
2D-06
4E-06
10H-25
550206
Description No.
Req'd.
Bucket Carrier Assembly Pin, Cylinder To Carrier Bolt,PinRetainer awshr, Pin Retainer Bucket Assembly — See Chart Below
Pin, Carrier To Bucket Bolt,PinRetainer Lkwshr, Pin Retainer Nut, Pin Retainer Pin, Cylinder To Bucket Bolt, Pin Retainer Nut, Pin Retainer Lkwshr, Pin Retainer Fitting, Carrier Grease Bushing,CarrierToBucket 1
2
2
2
2
2
2
2
2
2
2
2
2
4
Item
No.
Part
No.
No.
Req'd.
Description
16
550207Pin, Carrier To Guide Bar
2
17
2D-06Nut, Pin Retainer 2
18
4E-06Lkwshr, Pin Retainer 2
19
2C-648Bolt, Pin Retainer 2
20
2D-06Nut, Pin Retainer 2
BUCKET ASSEMBLY DATA
Width
Bucket
Assembly
No.
60"
552863
Cutting Edge
Replacement Kit
No.
940383
73"
550210
940174
79"
551717 Standard
940334
85"
551711
940175
CL IRK
EQUIPMENT
MICHIG1111
BUCKET INDICATOR
Item
No.
Part
No.
Description 1
4E-08Lkwshr, Pointer Arm to Bucket 1
2
616796Washer, Pointer Arm to Bucket. ..
2
3
550646Sleeve, Pointer Arm Mtg. 1
4
551373Bushing, Pointer Arm Mtg. 1
5
12H-15Fitting, Pointer Arm Grease 1
6
4F-08127 Pin, Clevis 1
7
551521*Pointer Arm Assembly 1
7A
551520* Pointer Assembly (Inc. 4, 5, & 7).
1
8
1F-414Cotter, Clevis Pin 1
9
2C-840Bolt, Pointer Arm to Bucket 1
10
4J-8300Clevis, Rod End 1
11
8D-08Nut, Rod End Clevis Jam 1
12
551613Indicator Rod Assy. (Inc. 10 & 11).
1
13
1F-414Cotter, ClevisPin 1
14
2D-08Nut, Cam Assembly Mtg. 1
15
4E-08Lkwshr, Cam Assembly Mtg.. 1
16
551515Cam Assembly (Inc. 16A & 17). .
1
16A
12H-15Fitting, Cam Assembly Grease ..
1
17
551373Bushing, Cam Assembly Mtg. 1
18
550646Sleeve, Cam Assembly Mtg. 1
19
2C-844Bolt, Cam Assembly to Bucket 1
20
4F-08127 Pin, Clevis 1
21
1C-1072 Bolt, Tube to Bucket Carrier 1
22
551523Tube 1
23
4E-10Lkwshr, Tube to Bucket Carrier..
1
24
1D-10Nut, Tube to Bucket Carrier 1
25
551644Spring 1
26
2D-08Nut, Pointer Arm to Bucket 1
*For 60" Bucket Assembly Use:
7552878 Pointer Arm Assembly 7A 552880 Pointer Assembly (Inc. 4, 5 & 7).
PM 1188
[ 12 ]
No.
Req'd.
CLARK
EQUIPMENT
MICHIGH
RADIATOR AND PARTS
Item
No.
Part
No.
Description
Item
No.
Part
No.
550588
Radiator
4H-30
Clamp, Radiator Hose 4
3
550590
Hose, Radiator — Upper 1
4
550591
Hose, Radiator — Lower 1
5
6
21D-08
Nut, Radiator to Frame 2
7
518233
Pad, Radiator to Frame 2
8
2C-828
Bolt, Radiator to Frame 2
9
2C-620
Bolt, Clip to Radiator 2
Clip, Radiator to Grille 2
514658
Omit
10
550589
Description
75A-8123 thru10222,
10247 thru 10251
1
1
2
PM 1188
No.
Req'd.
11
12
13
For Serial:
13 ]
4E-06
2D-06
73F-2
No.
Req'd.
10240&
75B-6123 thru 6200
75R-7123 thru 7154
75A-10223thru1 0 2 3 9,10241
thru 10246, 10252 & thereafter
75B-6201& thereafter
Lkwshr, Clip to Radiator
Nut, Clip to Radiator Drain Cock, Radiator 2
2
1
03
CO
0
z
0
Z
z
70
0
a
CU IRK
EQUIPMENT
tYIICHIGPfl
AIR CLEANER AND ATTACHING PARTS
Part
Item
No.
No.
Description
No.
Req'd.
ItemPart
No.No.
Hose, Air Cleaner — DIESEL 1
552896 For Serial:
75A-8123D thru 10222D, 10240D
& 10247D thru 10251D
75B-6123D thru 6200D
75R-7123D thru 7154D
75A-10223D thru 10239D,
10241D thru 10246D,
10252D & thereafter
75B-6201 D & thereafter
4H-38Clamp, Hose — GAS 4
550653 Cap, Air Cleaner 1
4550654 Air Cleaner 1
52C,410Bolt, Cleaner to Reservoir 4
64E-04Lkwshr, Cleaner to Reservoir 4
72D-04Nut, Cleaner to Reservoir 4
8550659 Strap, Air Cleaner 2
9
Hose, Air Cleaner — GAS 1
550658 For Serial:
75A-8123 thru 10222, 10240 &
10247 thru 10251
75B-6123 thru 6200
75R-7123 thru 7154
1M-16050 Effective with Serial:
75A-10223 thru 10239, 10241
10550655 Tube Assembly, Air Cleaner — GAS 1
11550660 Connector—GAS ONLY—For Serial: 2
75A-8123 thru 10222, 10240 &
10247 thru 10251
75B-6123 thru 6200
12A 4H-15 tClamp, Valve Cover Breather Hose
—GAS 2
13550657 Hose, Tube to Carburetor — GAS 1
1
14
Breather Hose Kit — DIESEL 1
942417 For Serial:
75A-8123D thru 10222D, 10240D
& 10247D thru 10251D
75B-6123D thru 6200D
75R-7123D thru 7154D
75A-10223D thru 10239D, 10241D
thru 10246D, 10252D & thereafter
15550660 Connector — DIESEL — For Serial: 2
75A-8123D thru 10222D, 10240D
& 10247D thru 10251D
75B-6123D thru 6200D
75R-7123D thru 7154D
15A 655281
Hose Nipple — DIESEL — Effective
with Serial: 75A-10223D thru 10239D,
10241D thru 10246D,
10252D & thereafter
16551756 Gasket, Adaptor to Manifold —
DIESEL
1
17550765 Intake Manifold Adaptor Assy. —
DIESEL
1
184E-05Lkwshr, Adaptor to Manifold —
DIESEL 4
191C-512 Bolt, Adaptor to Manifold — DIESEL 4
20
Clamp, Hose — DIESEL 2
4H-28For Serial:
75A-8123D thru 10222D, 10240D
& 10247D thru 10251D
75B-6123D thru 6200D
75R-7123D thru 7154D
4H-35Effective with Serial:
75A-10223D thru 10239D,
10241D thru 10246D,
10252D & thereafter
75R-7123 thru 7154
11A 655281
Hose Nipple — GAS ONLY — Effec-
tive with Serial: 75A-10223 thru 10239, 10241
12
No.
Req'd.
Description
Breather Hose Kit — GAS 942416 For Serial:
MUFFLER AND PARTS
75A-8123 thru 10222, 10240 &
ItemPart
No.No.
10247 thru 10251
Description
No.
Req'd.
75B-6123 thru 620 0
.
21550650 Muffler 22 550651 Manifold Adaptor — GAS 23550764 Manifold Adaptor — DIESEL 24550652 Clamp, Adaptor to Muffler 25551528 Clamp, Tail Pipe to Brace 75R-7123 thru 7154
75A-10223 thru 10239, 10241
PM 1188
[ 15 ]
1
1
1
1
14
15
C
z
r
X2
16
13
17
26
12
18
0
25
tn
24
oto
4
70
23
-11
22
20
21
27
19
28
33
29
0
0
30
34
35
31
36
32
1re
1.
071
37
49
1111°11111111111.111.11.11.1.1"
1.
50
39
38
51
0
52
41
53
42
43
46
47
45 44
ACCELERATOR PEDAL AND LINKAGE — DIESEL
T5-269
a
Z3
CUIRK
EQUIPMENT
ACCELERATOR PEDAL AND LINKAGE
Item
No.
Part
No.
1
2
3
4
5
6
7
8
9
10
11
12
61901 . 8
513005
1F-310
619018
513007
1F-310
513003
551090
513002
4E-04
1C-409
550624
13
553967
513008
514620
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
551178
2C-448
551016
4E-04
2D-04
550616
2C-410
2J-4200
8D-04
550619
4F-04051
1F-207
623829
623762
1F-316
551015
2C-410
4E-04
2D-04
4F-04051
Description
No.
Req'd.
Washer, Bell Crank Arm Bell Crank Bracket Ass'y. Cotter, Bracket to Bell Crank Arm..
Washer, Bell Crank Arm Bell Crank Arm Cotter, Rod to Bell Crank Arm .
Rod, Connector Spring, Shut Off Return Clip, Spring Return Lkwshr, Spring Return Clip Bolt, Spring Return Clip Guide, Shut Off Rod 1
1
1
1
1
1
1
1
1
1
1
1
Item
No.
34
35
36
37
38
39
40
Description No.
Req'd.
1F-207Cotter, Pedal Rod Yoke Pin 4E-04Lkwshr,BellCrank 2D-04Nut, Bell Crank 4F-04051 Pin, Accel. Rod Yoke 1F-207Cotter, Accel. Rod Yoke Pin 2J-4200Yoke, Accel. Rod 8D-04Nut, Yoke Jam Accelerator Rod Assembly 551759For Serial:
75A— 8123D thru 9638D & 9889D
75B — 6123D thru 6180D
75R — 7123D thru 7150D
553988For Serial:
75A — 9639D thru 9888D 9890D
thru 10222D, 10240D & 10247D
thru 10251D
75B — 6181D thru 6200D
75R — 7151D thru 7154D
75A — 1 0223D thru 1 0239D,
10241D thru 10246D, 10252D &
thereafter
75B -- 6201 D & thereafter
75R — 7155D & thereafter
42 2C-516Bolt, Accel. Rod Guide 43 550624Guide, Accel. Rod 44 4E-05Lkwshr, Accel. Rod Guide 45 2D-05Nut, Accel. Rod Guide 46 551090Spring, Pedal Return 47 8D-04Nut 48 941484Ball Joint, Accel. Rod to Pump—For
Serial— 9639D thru 9888D,
9890D thru 10222D, 10240D &
10247D thru 10251D 48A 2J-4200 tYoke, Accel. Rod to Pump — For
Serial 8123D thru9638D&
9889D 48B 4F-04051 tPin, Accel. Rod to Pump Yoke — For
Serial8123Dthru9638D&
9889D 48C 1 F-207tCotter, Accel. Rod to Pump Yoke Pin
—For Serial-8123D thru 9638D
& 9889D 49 619018Washer, Bell Crank Arm 50
14D-10Nut, Clevis Jam 51
4F-03038 Pin,Clevis....... ...........
1 F-208Cotter, Clevis Pin 52
53 2J-10109Clevis 1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
2
2
2
PM 1188
DIESEL
1
2
2
1
1
1
1
41
Shut Off Rod Assembly Cable — For Serial:
75A — 9639D thru 9987D except
9889D
75B6181D thru 6189D
For Serial:
75A-9988D thru 10222D, 10240D
& 10247D thru 10251D
75B — 6190D thru 6200D
75R — 7151D thru 7154D
75A — 10223D thru 10239D,
10241D thru 10246D, 10252D &
thereafter
75B — 6201D & thereafter
Knob, Shut Off Rod Bolt, Pedal Stop Stop, Pedal Lkwshr, Pedal Stop Bolt, Pedal Stop Bell . Crank. Ass'y. Bolt, Bell Crank Mtg. Yoke, Pedal Rod Nut, Pedal Rod Yoke Jam Rod,Pedal Pin, Pedal Rod to Pedal Cotter, Pedal Rod to Pedal Pin
Pedal, Accelerator Pin, Pedal to Bracket Cotter, Pedal to Bracket Pin Bracket, Pedal Pivot Bolt, Bracket to Floorboard Lkwshr, Bracket to Floorboard Nut, Bracket to Floorboard Pin, Pedal Rod Yoke Part
No.
MICHIGAll
[ 17 ]
1
CUIRK-
EQUIPMENT
MICHIGM1
ACCELERATOR PEDAL AND LINKAGE GAS
ItemPart
No.No.
Description
ItemPart
No.No.
No.
Req'd.
Description
No.
Req'd.
1
1 8D-04Nut, Ball Joint Jam 132 4J-4200 Yoke, Accel. Rod 2 551178Knob, Choke Rod 133 8D-04Nut, Accel. Rod Yoke Jam 1
3 2D-06Nut, Accel. Rod Guide 1
Accelerator Rod Assembly 34
4 4E-06Lkwshr, Accel. Rod Guide 1
511945For Serial:
5 550624Guide, Accel. Rod 1
75A-8123 thru 10222, 10240 &
6 551090Spring, Pedal Return 1
10247 thru 10251
7 2C-616Bolt, Accel. Rod Guide 1
75B-6123 thru 6200
8 2D-04Nut, Bracket to Floorboard. . . .. 2
75R-7123 thru 7154
9 4E-04 Lkwshr, Bracket to Floorboard 2
10 623762 Pin, Bracket to Pedal
1
75A-10223 thru 10239, 10241 thru
11 623829Pedal, Accelerator
1
10246, 10252 & thereafter
12 4F-04051 Pin, Pedal to Rod
1
13 2C-448Bolt, Pedal Stop
1
14 551016Stop, Pedal
1
1
Choke Rod Assembly 35
15 4E-04Lkwshr, Pedal Stop 1
551512For Serial:
16 2D-04 Nut, Pedal Stop 1
75A-8123 thru 1 0 2 2 2, 1 0 2 4 0 &
17 2C-410Bolt, Bell Crank Mtg 2
10247 thru 10251
18 4E-04Lkwshr, Bell Crank Mtg 2
75B-6123 thru 6200
19 2D-04 Nut, Bell Crank Mtg 2
75R-7123 thru 7154
20 4F-04051 Pin, Accelerator Rod Yoke 1
21 550616Bell Crank Assembly
1
75A-10223 thru 10239, 10241 thru
22 4J-4200 Yoke, Pedal Rod 1
23 8D-04 Nut, Pedal Rod Yoke Jam 1
75B-6201
& thereafter
24 550619Rod, Pedal 1
25 1F-207 Cotter, Pedal to Rod Pin
1
26 2C-410Bolt, Bracket to Floorboard. ... 236 551090
Spring, Choke Rod Return.. ..
27 551015Bracket, Pedal Pivot 137 941484
Ball Joint, Accel..l.
to Carb. ..
28 1F-316Cotter, Pedal Pin
138 4F-03038 Pin, Choke Rod to Carb. 29 1 F-207Cotter, Pedal Rod Yoke 139 1F-208
Cotter, Choke Rod to Carb. Pin. 30 4F-04051 Pin, Pedal Rod Yoke 140 4E-04
Lkwshr, Ball Joint to Carb. 31 1F-207 Cotter, Accel. Rod Yoke 141 8D-04
Nut, Ball Joint to Carb. PM 1188
[ 18
CUIRK
MICHIGIM
EQUIPMENT
FUEL LINES DIESEL
For Serial:
75A8123D Thru 9638D and 9889D
75B6123D Thru 6180D
75R7123D Thru 7150D
Item
No.
1
2
3
4
5
6
6A
6B
6C
7
Part
No.
Description No.
Req'd.
ItemPart
No.No.
552017
Return Line, Injector to Main Return
Line 6H-1
Clip, Tubes 59F-2
Connector, Inverted Flare Tube....
62F-5
Elbow --- 90° 69F-5
Shut Off Valve 552732
Clip, Fuel Line 1C-416 tBolt, Fuel Line Clip 1D-04
-1-Nut, Fuel Line Clip 4E-04
tLkwshr, Fuel Line Clip 552 302
ReturnLine Assembly,Engine to
Tank 10
11
12
13
14
15
16
17
18
1
2
2
19
20
.
8
940393
8A
552300
9
551331
21
22
23
24
25
Fuel Line Assembly Kit — For Serial
8123D thru 8498D Fuel Line Assembly — For Serial
8499D thru 9638D & 9889D....
Filter, Primary Fuel 26
PM 1188
[ 19 ]
940107
59F-6
31F-2
6H-9
2C-616
4E-06
2D-06
550757
2C-512
4E-05
2D-05
551336
550983
18F-2
19F-1
62F-2
5K-207
Description No.
Req'd.
Cartridge, Primary Fuel Filter 1
1
Connector, inverted Flare Tube.
Elbow — 90 ° 1
Clip, Return Line 1
Bolt, Bracket to Frame Lkwshr, Bracket to Frame 2
Nut, Bracken to Frame 2
Bracket, Filter Mtg. 1
Bolt, Filter to Bracket 4
Lkwshr, Filter to Bracket 4
Nut, Filter to Bracket 4
Hose, Filter to Pump 1
Hose, Engine to Return Line 1
Pipe Tee — 1/4 x 1/4 x 1/4 1
Bushing, Reducing — 1/4 x 1/8
Elbow — 90° Nipple — 1/4
1
1
1
19
0
1011121314 15
16
11 18
-11
0
z
z
em
In
28
212625 24
23
22
2
0
z
a
FUEL LINES - DIESEL
TS -267
CL/IRK
EQUIPMENT
MICHIGAn
FUEL LINES DIESEL
Effective with Serial
75A — 9639D and Thereafter Except 9889D
75B6181D and Thereafter
75R7151D and Thereafter
No.
Req'd.
Item
No.
Part
No.
Fuel Injection Pump See Index. 1
14F
2D-06
tNut, Bracket to Frame 1
ItemPart
No.No.
1
Description
Description No.
Req'd.
14G
4E-06
tLkwshr, Bracket to Frame 1
3553858 Filter, Secondary
1
15
59F-6
Connector, Inverted Flare Tube ... 1
3A 958485 Cartridge, Secondary Filter
1
16
553984
Fuel Line Assembly, Tank to Hand
1
229F-1Elbow — 90° 419F-3Bushing, Reducing — 3/8 x 1/41
1
Primer 562F-6Elbow — 90° 1
17
552732
Clip, Fuel Line to Frame 2
629F-1Elbow — 90° 1
18
2C-620
Bolt, Clip to Frame 1
7550984 Hose, Pump to Return Line 1
18A
2D-06
tNut, Clip to Frame 1
8551331 Filter, Primary
1
18B
4E-06
tLkwshr, Clip to Frame 1
8A 940107 Cartridge, Primary Filter
1
19
62F-5
Elbow — 90° 1
9550757 Bracket, Primary Filter Mtg.
1
20
69F-5
Shut Off Valve 1
Return Line Assembly 1
102C-512Bolt, Filter to Bracket
4
10A 2D-05 tNut, Filter to Bracket 21
4
552302
10B 4E-05tLkwshr, Filter to Bracket 4
For Serial:
10C 2C-616 tBolt, Bracket to Frame 2
75A — 9639D thru 9888D, 9890D
10D 2D-06 tNut, Bracket to Frame 2
thru 10222D, 10240D & 10247D
thru 10251D
10E 4E-06tLkwshr, Bracket to Frame 2
75B — 6181D thru 6200D
1159F-6Connector, Inverted Flare Tube. 1
75R7151D thru 7154D
12
Fuel Line Assembly 1
514606
553985 For Serial:
Effective Serial:
75A — 10223D thru 10239D,
75A — 9639D thru 9888D, 9890D
10241D thru 10246D, 10252D &
thru 10222D, 10240D & 10247
thereafter
thru 10251D
75B — 6201 D & thereafter
75B — 6181D thru 6200D
75R — 7151D thru 7154D
2262F-6Elbow — 90° 514605 Effective with Serial:
1
23553982 Fuel Line Ass'y, Primary to Second-
75A — 10223D thru 10239D,
ary Filter
1
10241D thru 10246D, 10252D &
24550757 Bracket, Secondary Filter Mtg. 1
thereafter
4
252C-512Bolt, Filter to Bracket. 75B — 6201D & thereafter 4
25A 2D-05 tNut, Filter to Bracket 75R — 7155D & thereafter 1359F-6Connector, Inverted Flare Tube. 125B 4E-05tLkwshr, Filter to Bracket 4
14692843 Pump, Hand Primer 125C 2C-616 tBolt, Bracket to Frame 2
14A 553986 -I- Bracket, Hand Primer Pump Mtg. .. 1 25D 2D-06 tNut, Bracket to Frame 2
14B 2C-1018 tBolt, Pump to Bracket 225E 4E-06tLkwshr, Bracket to Frame 2
14C 14D-10 tNut, Pump to Bracket 22619F-3Bushing, Reducing — 3/8 x 1
14D 12E-10 tLkwshr, Pump to Bracket 22729F-1Elbow — 90° 14E 2C-620 tBolt, Bracket to Frame t — Not Illustrated
PM 1188
1
128550876 Hose, Secondary Filter to Pump 1
[ 21 ]
CUIRK
EQUIPMENT
MICHIG1111
FUEL LINES - GAS
Item
No.
1
2
3
4
4A
5
6
7
8
8A
9
Part
No.
Description 550984
Hose, Fuel Line to Engine Omit
1 D-04
Nut, Clip to Fuel Line Lkwshr, Clip to Fuel Line 4E-04
619018 'Washer, Clip to Fuel Line Bolt, Clip to Fuel Line 1C-410
Bolt, Clip to Frame 2C-616
Clip, Fuel Line 6H-9
Fuel Tank — See Index
13F-04 tPipe Plug, Fuel Tank 69F-4
Shut Off Valve 10
552298
Item
No.
No.
Req'd.
Fuel Line Ass'y, Tank to Fuel Pump For Serial:
75A — 8499 thru 10222, 10240 &
Description
No.
Req'd.
10247 thru 10251
1
75B6123 thru 6200
75R — 7123 thru 7154
1
1
2
1
2
3
514608
For Serial:
75A — 10223 thru 10239, 10241
75B — 6201 & thereafter
75R — 7155 & thereafter
2
1
11
4E-06
Lkwshr, Clip to Frame 2
12
2D-06
Nut, Clip to Frame 2
1
13
Carburetor — See Index
Fuel Pump — See Index
14
15
PM 1188
Part
No.
[ 22 ]
620558
Elbow, Hose to Pump 1
I
CUIRK
MICHIG1111
EQUIPMENT
FRONT OF MACHINE
101112
43
4241 40
45
74
1
117 1 16 I 15114
21
20
22 23 24
25
38 375 3332 31
36 34
46 47 4
77 76 75
78
79
1 it
1 18
13 14 15 16 17 18 19
113
9 50 51 52 53 54
I1 1 I 5,15
3
82
61 62
II
38t0-P-48 -53A
64 63
2 1 70
71 6
838.4
111
2
103
124
125 126 127:
1
1
96
95
I
128_
102101 100 99
98 97
132133
1 134
1
1
149 146145 144
1
150 147 1 143
1
1
1
174
1
1
172 173Q1,-- 175 1
176_
1
165 166 167 i
1
I 168
171,-
1
177_
1
178.4
169 170 g, 160161 162 163 164
1
1
11
i
156155 15415 3
i 1
I 1
141 1I
_142 11 I
152 151
137136 135
I1
I1
I
I1
11
179
190
187 188191
1 1891192
182
1
183
184 185 186
1
0 i'-;;:_' i
221
138
140 139
207 206
16 215 I 213 220 21(9218 21 17 21
208
214 212 11 210209
I 1 200 199
204 20 201
202
205
TRANSMISSION
PM 1188
II
_195
197 196
[ 24
198
193
CUIRK
EQUIPMENT
TRANSMISSION ASSEMBLY
MODEL 75A
ItemPart
No.No.
A
Description
ItemPart
No.No.
No.
Req'd.
Transmission Assembly ...... . .1
*T-75A1 For Serial 8123 thru 9230 except
9180, 9191, 9195 thru 9213,
9218, 9222, 9226 & 9229.
T-75A3 (280071) Effective with Serial —
9180, 9191, 9195 thru 9213,
9218, 9222, 9226 9229, 9231
& thereafter
* Same as T-75A3 except for items 141 and 142 —
See below. For complete replacement use T-75A3.
1201951
2 209343
3 100949
4 206864
5 209340
5A 209341
5B 209342
Nut, Flange In put Flange & Deflector Assy (Inc. 3) Deflector, Input Flange Oil Seal, Input Shaft *Shim, Bearing Cap (.004) *Shim, Bearing Cap (.007) *Shim, Bearing Cap (.010) 1
Shaft, Input
1
6
800810For Serial Group "A" (See page 27)
220542For Serial Group "B" (See page 27)
1
7 SK203-97 Bearing, Input Shaft 1
8 SK203-97 Bearing, Input Shaft 9 SK203-96 Bearing, Quill Shaft
1
1
10 209368 Shaft, Quill
11 209369 Gear, Input Shaft Reverse (43
Teeth)
1
1
12 SK203-96 Bearing, Quill Shaft
1
13 221401Gasket, Cover 14 209392 *Shim, Clutch Bearing Cap (.004). 14A 209393 *Shim, Clutch Bearing Cap (.007). 14B 209394 *Shim, Clutch Bearing Cap (.010). 14C 221208 *Shim, Clutch Bearing Cap (.020). 15 209391Cap, Clutch Bearing 1
16 209387 Ring, Hub Oil Sealing 2
17 §Clutch Drum Hub Ass'y (See 224) 1
18 SK251-92 Ring, Hub Retainer
1
19 208775Piston, Clutch
1
20 209385Drum, Clutch 1
21 208773Disc, Clutch Outer 5
22 208760Plate, Clutch Disc End 1
23 SK250-91 Ring, End Plate Retainer
1
24
Hub, Clutch Disc 1
220539ForSerial Group "B" (See page 27)
25 209358Clutch Cover Assy. 1
26 1C-614Bolt, Cover
10
27 4E-06 - Lkwshr, Cover 10
28 SK251-63 Ring, Disc Hub Retainer 2
29 209709 Spring, Clutch Release 10
*— As Required
§ — Not Sold Separately
PM 1188
[ 25
Description
No.
Req'd.
30209928Disc, Clutch Inner 31208776Ring, Piston Outer Sealing 32208777Ring, Piston Inner Sealing 33209932Pin, Relief 34209389Spring, Relief 34A 209937 tWasher, Relief Spring 34B 220678 tGuard, Relief Spring 34C 619023 tWasher, Clutch Drum Balance.
35100284Bolt, Drum to Hub 361C-718Bolt, Bearing Cap 374E-07Lkwshr, Bearing Cap 3825K-30016 "0" Ring, Bearing Cap 39209377Gear, Input Shaft Forward (45T).
40209339Cap, Input Shaft Bearing 414E-07Lkwshr, Bearing Cap 421C-718Bolt, Bearing Cap 431 F-424Cotter, Flange Nut 44SK251-63 Ring, Disc Hub Retainer 45208760Plate, Clutch Disc End 46209928Disc, Clutch Inner 47209385Drum, Clutch 48208776Ring, Piston Outer Sealing 49208775Piston, Clutch 50SK251-92Ring, Hub Retainer 51 §Clutch Drum Hub Assy (See 224).
52209387Ring, Hub Oil Sealing 53209391Cap, Clutch Bearing 5425K-30016 "0" Ring, Bearing Cap 55209392*Shim, Clutch Bearing Cap 55A 209393*Shim, Clutch Bearing Cap 55B 209394 *Shim, Clutch Bearing Cap 55C 221208*Shim, Clutch Bearing Cap 56SK203-96 Bearing, 1st — 3rd Shaft 57209368Shaft, Quill 58SK203-96Bearing, 1st — 3rd Shaft.....
59SK203-97Bearing, 1st — 3rd Shaft 60SK203-97 Bearing, 1st — 3rd Shaft 61209364Cap, 1st — 3rd Shaft Bearing..
621C-718Bolt, Bearing Cap 634E-07Lkwshr, Bearing Cap 64209365*Shim, Bearing Cap (.004) 64A 209366*Shim, Bearing Cap (.007) 64B 209367 *Shim, Bearing Cap (.010) 65209375Gear, 1st — 3rd Drop (44T). ..
5
1
1
1
1
1
1
4
8
4
4
1
1
1
4
4
1
2
1
5
1
1
1
1
1
1
1
1
Shaft, 1st — 3rd Drive 66
1
67209374Gear, 1st — 3rd Drive (29T). .
684E-07Lkwshr, Bearing Cap 691C-718Bolt, Bearing Cap 70100284Bolt, Drum to Hub 71209389Spring, Relief 71A 209937 tWasher, Relief Spring 71B220678tGuard, Relief Spring 1
4
4
8
1
1
1
1
1
1
1
1
1
4
4
1
CLMIK
EQUIPMENT
mICHIGAn
TRANSMISSION ASSEMBLY (Continued)
MODEL 75A
ItemPart
No.No.
Description
No.
Req'd.
71C 619023 tWasher, Clutch Drum Balance...
72 209932Pin, Relief 73 208777 Ring, Piston Inner Sealing 74 208773Disc, Clutch Outer 75 209709Spring, Clutch Release 76 SK250-91 Ring, End Plate Retainer ItemPart
No.No.
Hub, Clutch Disc 77
1
1
1
1
1
1
1
1
.1
1
2
1
1
1
1
5
1
2
1
4
4
100 SK250-91 Ring, End Plate Retainer 101 209709 Spring, Clutch Release 102 209928Disc, Clutch Inner 103 208776Ring, Piston Outer Sealing
104 208777Ring, Piston Inner Sealing 105 209932Pin, Relief 106 209389Spring, Relief 106A 209937 tWasher, Relief Spring 106B 220678 tGuard, Relief Spring 106C 619023 tWasher, Clutch Drum Balance...
107 100284Bolt, Drum to Hub 108 1C-718Bolt, Bearing Cap 109 4E-07 Lkwshr, Bearing Cap 110 209392 *Shim, Clutch Bearing Cap (.004).
110A 209393 *Shim, Clutch Bearing Cap (.007). •
1 10B 209394 *Shim, Clutch. Bearing Cap (.010). .
110C 221208 *Shim, Clutch Bearing Cap (.020). •
111 209368Shaft, Quill 112 220395Gear, 2nd — 4th Shaft (32T). ..
113
Shaft, 2nd - 4th Drive 800811 For Serial Group "A" (See page 27)
220543
For Serial Group "B" (See page 27)
1
10
5
1
1
1
1
1
1
4
8
4
4
138 Shaft, Reverse Drive ..... .
For Serial Group "A" (See page 27)
800809
220541
For Serial Group "B" (See page 27)
1
139
209371
140
209368
142
209354
220669
143209353
144209392
144A 209393
144B 209394
144C 221208
1454E-07
1461C-718
147100284
148209389
148A 209937
148B 220678
148C 619023
149
150209932
151208777
1
[26
Gear, Reverse Drive (54T)
Shaft, Quill
141
Pipe, Sump Intake
209103T-75A1
220673T-75A3
*— As Required
§ — Not Sold Separately
PM 1188
No.
Req'd.
114SK251-26 Ring, 2nd — 4th Gear Locating. 1
115209417*Shim, Bearing Cap (.004) 115A 209418 *Shim, Bearing Cap (.007) 115B209419*Shim, Bearing Cap (.010) 4
1164E-07Lkwshr, Bearing Cap
4
1171C-718Bolt, Bearing Cap
1
118209357Clutch Cover Assy. 2
119SK251-63Ring, Disc Cover Retainer
1
120SK250-91Ring, End Plate Retainer
5
121209928Disc, Clutch Inner
1
122209385Drum, Clutch
1
123208775Piston, Clutch
1
124SK251-92 Ring, Hub Retainer
2
125209387Ring, Hub Oil Sealing
1
126209391 Cap, Clutch Bearing....
1
12725K-30016 "0" Ring, Bearing Cap
128 §Transmission Case Assy. (See 222) 1
129SK203-96 Bearing, Reverse Shaft
1
1
130SK203-96 Bearing, Reverse Shaft ...... . .
1
131SK203-97 Bearing, Reverse Shaft... .
1
132SK203-97 Bearing, Reverse Shaft
1
133209364Cap, Reverse Shaft Bearing
1341C-718Bolt, Bearing Cap
4
1354E-07Lkwshr, Bearing Cap
4
136209365*Shim, Bearing Cap (.004) 136A 209366*Shim, Bearing Cap (.007) 136B209367*Shim, Bearing Cap (.010). . .
137209372Gear, Reverse Idler (52T) ...
4
1
1
5
10
1
78 209416Cap, 2nd — 4th Shaft Bearing..
79 SK203-98 Bearing, 2nd -- 4th Shaft 80 209421 Gear, 2nd — 4th High (57T). ..
81 SK203-99 Bearing, 2nd — 4th Shaft 82 SK203-96 Bearing, 2nd — 4th Shaft 83 209369Gear, 2nd — 4th Drive (43T)...
84 SK202-96 Bearing, 2nd — 4th Shaft 85 221401Gasket, Cover 86 25K-30016 "0" Ring, Bearing Cap 87 209391Cap, Clutch Bearing 88 209387Ring, Hub Oil Sealing 89 §Clutch Drum Assy. (See 224). ..
90 SK251-92 Ring, Hub Retainer 91 208775 Piston, Clutch 92 209385Drum, Clutch 93 208773Disc, Clutch Outer 94 208760Plate, Clutch Disc End 95 SK250-63 Ring, Disc Hub Retainer .....
96 209358Clutch Cover Assy 97 1C-614Bolt, Cover 98 4E-06 Lkwshr, Cover 99
Hub, Clutch Disc 800811For Serial Group "A" (See page 27)
Description
1
1
1
1
Oil Screen & Frame Assembly. .
T-75A1
T-75A3
Gasket, Sump Cover..... 2
*Shim, Clutch Bearing Cap (.004). .
tShim, Clutch Bearing Cap (.020)
Lkwshr, Bearing Cap
4
Bolt, Bearing Cap
4
Bolt, Drum to Hub
8
Spring, Relief
1
tWasher, Relief Spring .... . . 1
tGuard, Relief Spring
1
tWasher, Clutch Drum Balance
4
§Clutch Drum Hub Assy. (See 244) 1
Pin, Relief
1
Ring,PistonInner Sealing
1
CUIRK
EQUIPMENT
MICHIG1111
TRANSMISSION ASSEMBLY (Continued)
MODEL 75A
Item
No.
152
153
154
155
Part
No.
Description
No.
Req'd.
208776
208773
209709
208760
Ring, Piston Outer Sealing Disc, Clutch Outer Spring, Clutch Release Plate, Clutch Disc End 800809
220539
Hub, Clutch Disc For Serial Group "A"
For Serial Group "B"
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
180A
181
181A
182
182A
183
184
185
186
Gasket, Cover 209370
Lkwshr, Cover 4E-06
Bolt, Cover 1C-614
Nut, Flange 205928
Deflector, Out-put Flange 100949
Oil Seal, Out-Put Shaft 206864
Cap, Rear Out-Put Bearing 209428
Bearing, Out-Put Shaft 713997
Oil Seal, Shift Shaft 209435
Shift Rail, 2 & 4 Wheel Drive 209434
Shift Fork, 2 & 4 Wheel Drive 209433
Screw, Shift Fork 201566
Housing, Rear Out-Put Shaft 209430
Ball, Mesh Lock 10J-12
Spring, Mesh Lock 201844
Gasket, Cover Plate 209432
Plate, Rear Housing Cover 209431
Lkwshr, Cover Plate 4E-06
Bolt, Cover Plate 1C-612
Sump Cover 209352
Lkwshr, Sump Cover 4E-06
Bolt, Sump Cover 1C-616
Drain Plug (Magnetic).... .
201120
High Gear & Bushing Assy. (29T) 209396
209398 tBushing, High Gear (29T) Out-Put Shaft & Bushing Assy.• • • •
209423
209425
1- Bushing, Out-Put Shaft Low Gear & Bushing Assy. (55T). 209399
tBushing, Low Gear (55T) 209402
SK203-96 Bearing, Out-Put Shaft Cap, Out-Put Shaft Bearing 209692
Oil Seal, Out-Put Shaft 206864
209414
Out-Put Flange & Deflector Assy.
(Inc.200) 187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
209403
209406
209405
4E-06
1C-616
209404
208871
10J-12
13F-04
201844
201566
1F-432
205928
100949
1C-718
Fork, High & Low Shift Gasket, Hi & Low Support Support, Hi & Low Shift Shaft Lkwshr, Support Bolt, Support Shaft, Hi & Low Shift Oil Seal, Support Ball, Mesh Lock (Support) Plug, Mesh Lock (Support) Spring, Mesh Lock (Support) Lock Screw, Shift Fork Cotter, Flange Nut Nut, Flange Deflector, Flange Bolt, Out-Put Shaft Bearing Cap Item
No.
202
203
203A
203B
204
205
206
207
208
209
210
211
212
213
1
5
10
1
1
1
16
16
1
1
1
1
1
1
1
214
215
216
217
218
219
220
221
222
1
1
1
1
1
1
1
6
6
1
14
14
1
1
1
1
1
223
224
225
226
227
234
1
1
1
1
1
235
236
237
238
239
240
241
242
1
1
Description No.
Req'd.
Lkwshr, Out-Put Shaft Bearing Cap
4E-07
*Shim, Bearing Cap (.004) 209701
209702 *Shim, Bearing Cap (.007) *Shim, Bearing Cap (.010) 209703
Thrust Washer, Out-Put 'Gear 209407
Oil Ring, Low Gear 209673
Hub, Hi & Low Shift 209409
Thrust Washer, Out-Put Gear .
209407
SK203-96 Bearing, Out-Put Shaft SK250-30 Retainer Ring, Out-Put Shaft Bearing
Shim, Rear Out-Put Shaft Housing
209411
Lkwshr, Rear Housing 4E-07
Bolt, Rear Housing 1C-720
SK251-64 Locating Ring, Out-Put Shaft Bearing Shift Hub, Rear Out-Put Shaft. 209427
Shaft, Rear Out-Put 209426
SK250-74 Ring, Rear Out-Put Shaft Locating .
Gasket, Bearing Cap 209429
Lkwshr, Bearing Cap 4E-07
Bolt, Bearing Cap 1C-718
Flange & Deflector Assy. (Inc. 161)
209414
Cotter, Out-Put Flame Nut 1F-432
Transmission Case Assy. (Inc. 128,
800815
141, 142, 143, 176, 177, 178,
179, 226 & 227)
Clutch Group Assy. (Inc. 14 thru 38)
209362
Clutch Hub & Ring Assy. (Inc. 16 &
800648
17) Low Gear & Oil Ring Assy. (Inc.
800656
182 & 205) 19F-8
tReducing Bushing % x 34"•
19F-16
tReducing Bushing 1 x 1 1/4".
13F-12
1- 0i1 Level Plug ( 3/4" Square
projecting) TRANSMISSION MOUNTING PARTS
550572
1-Trans. Mtg. Bracket Assy. - R.H 550576
-I-Trans. Mtg. Bracket Assy. - L.H. .
550575
fTrans. Mtg. Pad 14C-840 -f Bolt, Mtg. Bracket to Frame... 2D-08
tNut, Mtg. Bracket to Frame 2C-1044 tBolt, Mtg. Bracket to Trans. tNut, Mtg. Bracket to Trans. 2D-10
4E-10
-I- Lkwshr, Mtg. Bracket to Trans..
4
1
1
1
1
1
1
1
7
7
1
1
1
1
1
4
4
1
1
1
1
1
1
1
2
4
8
8
8
8
1
1
1
Serial Group "A"
8123 thru 9253, 9255 thru 9267, 9269 thru 9284, 9290,
9291, 9297, 9299, 9300, 9302, 9304, 9313, 9316,
9322, 9326, 9354, 9359, 9361, 9362, 9377, 9397,
9417, 9494, 9521, 9522 & 9524.
1
Serial Group "B"
9254, 9268, 9285 thru 9289, 9292 thru 9296, 9298,
9301, 9303, 9305 thru 9312, 9314, 9315, 9317 thru
9321, 9323, 9324, 9325, 9327 thru 9353, 9355 thru
9358, 9360, 9363 thru 9376, 9378 thru 9396, 9398
thru 9416, 9418 thru 9493, 9495 thru 9520, 9523,
9525 and thereafter.
4
t - Not Illustrated
*- As Required
§ - Not Sold Separately
PM 1188
Part
No.
[ 27 ]
CLARK
minion
EQUIPMENT
TRANSMISSION ASSEMBLY
MODEL 75B
ItemPart
No.No.
Description
MODEL 75R
Transmission Assembly A
*1-75B1
T-75B2
Item
Part
No.
No.
No.
Req'd.
Description
Transmission Assembly
1
For Serial — 6123 thru 6163 --
*T-75R1
No.
Req'd.
For Serial —. 7123 thrt, 7145 —
Same as T-75A1 except the fol-
Same as T-75A1 except the fol-
lowing parts are not used.
lowing parts are not used.
Effective with Serial — 6164 and
T-75R2
Effective with Serial — 7146 and
thereafter --- Same as T-75A3
thereafter — Same as T-75A3
except the following parts are
except the following parts are
not used.
not used.
*For complete replacement use T-75B2
1
*For complete replacement use T-75R2
162 206864
Oil Seal ......
163 209428
Cap, Rear Output Bearing 162
206864
Oil Seal
209428
Cap, Rear Output Bearing 1
1
164 713997
Bearing, Output Shaft 163
165 209435
Oil Seal, Shift Shaft . . .....
164
713997
166 209434
Shift Rail, 2 & 4 Wheel Drive 165
209435
Oil Seal, Shift Shaft 1
Shift Fork, 2 & 4 Wheel Drive 166
209434
Shift Rail, 2 & 4 Wheel Drive..
1
168 201556
Screw, Shift Fork 167
209433
Shift Fork, 2 & 4 Wheel Drive.
169 209430
Housing, Rear Output Shaft 168
201556
Screw, Shift Fork 1
170 10J-12
Ball, Mesh Lock 169
209430
Housing, Rear Output Shaft 1
171 201844
Spring, Mech. Lock 170
10J-12
Ball, Mesh Lock 1
201844
Spring, Mesh Lock 1
173 209431
209432
181 209423
Output Shaft & Bushing Assy.
173
209431
186 209414
Output Flange & Deflector Assy 181
209423
Output Shaft & Bushing Assy 1
200 100949
Deflector, Flange 186
209414
Output Flange & Deflector Assy., 1
Retaining Ring, Output Shaft
200
100949
Deflector,Flange
1
209
SK250-30
Retaining Ring, Output Shaft Brg.
1
167 209433
172 209432
209 SK250-30
Bearing 213 SK251-64
214 209427
215 209426
216 SK250-74
217 209429
Locating Ring, Output Shaft Bearing
213
SK251-64
Locating Ring, Output Shaft Brg 1
Shift Hub, Rear Output Shaft....
214
209427
Shift Hub, Rear Output Shaft 1
Shaft, Rear Output 215
209426
Locating Ring, Rear Output Shaft 216
SK250-74
Locating Ring, Rear Output Shaft 1
209429
The following parts are added:
The following parts are added:
181 209408
209408
tRetainer, Output Shaft Bearing...
181A 209410
tRetainer, Output Shaft Brg 1
181B 209412
t Cap, Output Shaft Rear Oil 181B 209412
1- Cap, Output Shaft Rear Oil 1
181C 209413
tSpacer, Output Shaft 181C 209413
1- Spacer, Output Shaft 1
181A 209410
PM 1188
[28
1
CUIRK
EQUIPMENT
NOTES
PM 1188
[ 29
MICHIGAll
CLARK
EQUIPMENT
MICHIGAll
8
27
10
13
1516 17 18
CONTROL COVER
3816 -P -48- 55G
[ 30 ]
CLARK
CONSTRUCTION MACHINERY DIVISION.
EQUIPMENT
MICHIG1111
TRANSMISSION CONTROL COVER PARTS
Item
No.
Port
No.
800657
Description No.
Req'd.
Control Cover & Valve Assy. (Inc.
1thru 29) 1
Item
Part
No.
No.
Description
No.
Req'd.
17
617337
Seal, Shutoff Valve Stop 1
18
SK250-93
Ring, Shutoff Valve Stop Retaining
1
1
208812
Seal, Selector Arm Shaft Oil 2
19
6E-06
Lkwshr, Control Valve Bolt 4
2
619027
Washer, Selector Arm Shaft 2
20
1C-626
Bolt, Control Valve 4
3
SK251-90
Ring, Selector Arm Shaft Washer
Retaining 21
209894
Guide, Valve Spring 1
2
22
208807
Selector Valve (See 29) 2
23
SK250-93
Ring, Shutoff Valve Spring
Retaining 4
104942
Breather Assembly 1
5
208805
Valve,Bleeder 1
6
209378
Cover, Control 1
24
208809
Pin,Selector Valve Link 2
7
25K-30016
5
25
208810
Pin,Selector ValveLink Clevis .
2
8
209379
Gasket, Control Cover 1
26
209382
Link, Selector Valve 2
9
203647
Spring, Selector Valve Detent 2
27
209874
Ball Stop, Selector Valve Detent.
1
10
10J-12
Ball, Selector Valve Detent Spring
2
28
1F-208
tCotter, Valve Link Clevis 2
11
209690
Selector Arm & Shaft Assy. 2
29
209381
Selector Valve Assy. (Inc. 22, 24,
& 26) 2
12
209380
Housing, Selector Valve 1
13
220363
Spring, Shutoff Valve 1
14
208815
Valve, Shutoff 1
15
208820
Cup, Shutoff Valve Sealing 1
16
209878
Stop, Shutoff Valve 1
Ring t — Not Illustrated
PM 1188
[ 31 ]
30
13F-02
Plug, Control Cover Oil Passage 5
31
1C-718
tBolt, Control Cover to Case 9
32
4E-07
t Lkwshr, Control Cover to Case 9
33
800653
Selector Control Valve Assy. (Inc.
12 thru 18, 21 thru 24 & 26). .
24
.25
2322 --(tt
11P-6 217
13 16 17 18 19
10II12 1314
8
2!
28 29
20
45 44
43 42 41 40 39
38 37 36 35
33 32
34
31I
30
WIN .1110MO
••■■••■■•■ 1.1.11■1111.
_58
3608 - P - 83-56
F-59
.56-1
SI
55
60
4647 48 49
5052S3
54
II
61 62 63 64 65
1
66
85 84 8382
III
111
81 80 79 78 7776 75 74 71 70 69 68 67
73 72
3608-P-83-56
TORQUE CONVERTER
.
CUIRK
MICHIGH
EQUIPMENT
TORQUE CONVERTER ASSEMBLY
MODEL 75 SERIES
75-B
75-A
75-R
6123 thru 6139 7123 thru 7144
Column 1
For Serial N
8123 thru 8348, 8351,
8352, 8356, 8364 thru
8367, 8458 & 8461
Column 2
For Serial No.
8349, 8350, 8353, 8354, 8355,
8357 thru 8363, 8368 thru
8430, 8432 thru 8457, 8459,
8460, 8462 thru 8476, 8481 & 8483
Column 3
For Serial No.
8431, 8477 thru 8480,
8482, 8484 thru 9484, 9519
thru 9532
6140 thru 61757145 thru 7150
Column 4
For Serial No.
9485 thru 9518, 9533 thru
10222, 10240 & 10247 thru
10251
6176 thru 62007151 thru 7154
Use C-303-1 list
for Serial No.
10223 thru 10239,
10241 thru 10246,
10252 & thereafter
6201 & thereafter 7155 & thereafter
Column 1 is complete as to part number listings.
Columns 2, 3, and 4 use same items as indicated in Column 1 except where indicated.
No.
Item
Description
No.
TORQUE CONVERTER MODEL
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
20A
21
1
2
3
4
C-75-1
C-75-2
C-75-3
C-75-6
See Note "A"
2C-618
See Note "A"
SK200-36
209596
209688
SK251-23
209319
209948
209597
209320
SK250-8
SK200-36
25K-40508
209595
619023
6E-06
2D-06
619023
209313
201553
25K-40600
See Note "A"
See Note "A"
213445
See Note "A"
See Note "A"
220483
209596
209688
209332
209333
209332
209333
209597
209321
209321
209595
209311
209311
Req'd
Converter Drive Gear Bolt, Impeller to Drive Disc Converter Disc Assembly Bearing, Drive Disc Hub Converter Turbine Hub, Converter Turbine Ring, Thrust Washer Ret. — Front Washer, End Plate Thrust — Front Spring, Sprag Converter Member Washer, End Plate Thrust — Rear Ring, Hub Bearing Ret. Bearing, Converter Impeller Hub "0" Ring, Impeller to Hub Impeller, Converter Washer, Impeller to Drive Disc Lockwasher, Impeller to Drive Disc Nut, Impeller to Drive Disc Washer, Impeller to Hub Bolt, Impeller to Hub tlockwire, Impeller to Hub Bolt "0" Ring, Converter Support 1
30
1
1
1
1
1
1
2
1
1
1
1
1
1
30
30
30
6
6
1
1
Note "A" — Use 940548 Kit for Gas Powered and 940549 Kit for Diesel Powered units. This kit includes necessary
parts to convert converter disc assembly, converter drive and driven gears and flywheel to latest design identified by
13 1/8 bolt circle on converter drive gear. After conversion has been made use column 4 for replacement items.
PM 1188
1
33 ]
CLARK
EQUIPMENT
MICHIGEM
MODEL 75 SERIES
Item
No.
No.
Description
Req'd
1
2
3
4
C-75-1
C-75-2
C-75-3
C-75-6
221023
221023
221023
209775
209782
209782
22Seat, Pressure Relief Ball (See Item 87) .1
1
23Spring, Oil Pressure Relief 1
24Plug, Oil Cooler Line 1
25Seal, Oil Cooler Line Plug 26Ball, Oil Pressure Relief 1
1
27Housing, Converter (See Item 87) 6
28Lockwasher, Converter Hsg. to Support 29Bolt, Converter Hsg. to Support 6
1
30Plug, Filler 1
31Converter Support Assembly 1
32Ring, Converter Support Oil 33Seal, Converter Support Oil 1
1
34"0" Ring, Impeller to Drive Disc Converter
Impeller
1
35Hub,
Impeller
Hub
Bearing
Locating
.
36Ring,
1
1
37Ring, End Plate Retainer 38Overrunning Clutch End Plate and
Bushing Assembly 1
1
39Outer Race, Overrunning Clutch 40Overrunning Clutch Assembly
(Inc. Item 9) 1
41Overrunning Clutch End Plate and
Bushing Assembly 1
42Ring, End Plate Retainer 1
1
43Ring, Turbine Hub Retainer 44Washer, Turbine to Hub 6
45Bolt, Turbine to Hub 6
45A tLockwire, Turbine to Hub Bolt 1
46Shaft, Main Drive Gear 1
47Ring, Main Drive Gear Bearing Ret 1
48Ring, Main Drive Gear Bearing Loc AR
48ARing, Main Drive Gear Bearing Loc AR
48BRing, Main Drive Gear Bearing Loc AR
48CRing, Main Drive Gear Bearing Loc AR
49Nut, Main Drive Gear Retainer 1
50Ring, Oil Pump Shaft Piston 1
51"0" Ring, Converter Unit Pump 1
52Gasket, Converter Unit Pump 1
NSS
209188
208783
208789
10J-16
NSS
6E-08
2C-820
13F-12
220706
209307
209778
209322
209775
SK251-70
SK250-9
53Gear, Output Shaft 1
209336
54"0" Ring, Oil Tube 2
25K-30N 6
.:-30018
25K-30018
25K-30018
1
209338
20Y869,
209869
209869
56Valve, Pressure Regulator 1
209815
57Seal, Pressure Regulator Plug
1
209818
58Plug, Pressure Regulator 59Spring, Pressure Regulator 1
209817
55Oil Tube, Cover to Case 209316
209315
209314
209316
SK250-9
SK251-28
619023
209313
201553
220491
SK251-38
SK250-96
SK250-97
SK250-98
SK250-99
207949
209781
25K-30020
220701
1
209816
60Stud, Vehicle Pump Mounting
205096
6
N.S.S. — Not Sold Separately AR — As Required
PM 1188
[
34 I
CLARK
miCHscAn
EQUIPMENT
MODEL 75 SERIES
No.
Item
Description
No.
Req'd
2
1
C-75-1
61
Shim, Output Shaft Bearing alp AR
209340
61A
209341
61B
Shim, Output Shaft Bearng Cap AR
Shim, Output Shaft Bearing Cap AR
62
Cap, Output Shaft Bearing 1
209339
63
64
Seal, Output Shaft Oil. 1
206864
Deflector 1
100949
65
Flange & Deflector Assy. (Inc. Item 64).
1
209343
66
Cotter, Flange Nut 1
1F-432
67
Nut, Output Shaft Flange 1
201951
68
Bolt, Output Shaft Bearing Cap 4
C-75-2C-75-3C-75-6
1C-720
4E-07
4E-07
69
70
71
Bolt, Cover to Housing 4
12
Lockwasher,. Cover to Housing 12
72
Cover, Housing 1
NSS
73
"0" Ring, Housing Cover 1
209294
74
SK203-97
75
Spacer, Output Shaft Gear 1
209337
76
Shaft,Output 1
209334
1C-720
77
SK203-97
78
Gasket, Converter Unit Pump 2
220699
79
Converter Unit Pump Assembly
1
940384
6E-06
80
Lockwasher, Pump to Converter Cover.
6
81
Bolt, Pump to Converter Cover 6
1C-636
82
Shaft, Oil Pump 1
209779
83
Gear, Main Drive 1
209299
84
Bearing, Main Drive Gear 1
658016
85
Ring, Main Drive Gear Shaft Oil 1
209304
86
Plug, Drain-Magnetic 1
201120
87
Converter Housing Cover Assembly
1
800655
88
Dowel, Housing to Cover 1
102381
(Inc Items 22, 27, 70, 71 and 72). .
4
209342
Lockwasher, Output Shaft Bearing Cap.
(Inc. Items 51, 52 and 78) 3
TORQUE CONVERTER MOUNTING PARTS
Item
No.
No.
Description 1
Req'd
C-75-1
*le89
Bolt, Torque Converter to Flywheel 8
1C-616
90
Lockwasher, Torque Converter to Flywheel
8
4E-06
91
Bolt, Torque Converter to Flywheel
Housing 92
12
1C-620
12
4E-06
Lockwasher, Torque Converter to
Flywheel Housing
AR — As Required PM 1188 N.S.S. — Not Sold Separately
[
35
1
2
C-75-2
3
4
C-75-3
C-75-6
24
25
2
101121314
1516 17 18
26
22—
Icoil
I
19
21
27 28
—20
II
0
-
45 44
43 42 41 40 3938 37 36 35 34
29
33 3231
—
30
0
z
316
70
60 61 62
57
4647 48
49
50
51
\ 1 /
64
58 59 " 'win
63.)
52 53
65 66
1
68
z
m
—77
90
79
80
4,
• .81
82
8384 85 86 87
II
LI
0
\-94
3609-P-87-36
z
95
109108107
I0
TORQUE CONVERTER
102
104
03
96
I
\
97
92 91 90 89
I93
100 99 98
88
CI
CUIRK
mIeHiGan
EQUIPMENT
MODEL 75 SERIES
75-A10223 thru 10239, 10241 thru 10246, 10252 and thereafter
75-B6201 and thereafter
75-R7155 and thereafter
No.
Item
Part No.
No.
C-303-1
213445
2
2C-618
3 220483
4SK200-36
5
220507
220493
SK251-23
8 209319
209948
9
10220488
209320
11
SK250-8
13
SK200-36
14
25K-40508
15
209311
16 619023
17
6E-06
18
2D-06
19619023
20
209313
20A
201553
21
25K-40600
22
208788
23
209188
24
220847
25
221023
26
10J-16
27
6E-08
28 2C-820
29
800872
30
201120
31
220706
32
209307
33_1209778
34r
209322
35
209782
36
SK251-70
SK250-1
16
38 220480
39
220479
40
221947
41
220480
42
SK250-1 16
4 SK251-28
44'
619023
45
209313
DescriptiqT
4 y.k-f-e
Torque Converter Assembly (280453) Gear, Converter Drive (See 120)
Bolt, Impeller to Drive Disc Converter Disc Assembly (See 120)
Bearing, Disc Hub ..... 2.3 SR
Turbine, Converter
Hub, Turbine
Ring, Front Thrust Washer, Retaining
Washer, Front Thrust
Spring, Sprag
Reaction Member, Converter (See 122)
Washer, Rear Thrust
Ring, Impeller Hub Bearing, Retainer
Bearing, Impeller Hub
"0" Ring, Impeller to Hub
Impeller, Converter
Washer, Impeller to Drive Disc Lkwshr, Impeller to Drive Disc Nut, Impeller to Drive Disc Washer, Impeller to Hub Bolt, Impeller to Hub Lockwire, Impeller to Hub "0" Ring, Converter Support
Seat, By-Pass Ball
Spring, By-Pass
Fitting, By-Pass Plug
Seal, By-Pass Plug
Ball, By-Pass
Lkwshr, Converter Support to Housing Bolt, Converter Support to Housing
Housing, Converter (See 121)
Plug, Magnetic Drain
Converter Support Assembly Ring, Converter Support Oil
Seal, Converter Support Oil
"0" Ring, Impeller to Drive Disc
Hub, Converter Impeller
Ring, Impeller Hub Bearing Locating
Ring, End Plate Retainer
End Plate and Bushing Assembly
Outer Race, Reaction Member (See 122) Over-running Clutch Assembly (Inc. Item 9)
End Plate & Bushing Assembly
Ring, End Plate Retainer
Ring, Turbine Hub Retainer Washer, Turbine to Hub Bolt, Turbine to Hub
N.I. --- Not Illustrated
AR — As Required
PM 1188
[37 1
Req'd
1
1
30
1
1
1
1
1
1
2
1
1
1
1
1
1
30
30
30
6
NI AR
1
1
1
1
1
1
6
. .....6
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
8
8
CUIRK
EQUIPMENT
flICHIcAn
MODEL 75 SERIES
No.
Item
No.
45A
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
77A
78
79
80
81
82
83
84
85
86
87
88
89
90
91
91A
91B
92
93
94
Description
Part No.
201553
221073
209304
658016
220492
221074
209779
209781
209336
209337
SK250-12
SK200-48
SK250-130
851240
220987
25K-30018
209869
25K-30018
221082
221072
851240
SK250-130
SK250-12
221084
220978
25K-40024
660178
220981
220983
25K-30018
220982
N.S.S.
1C-820
1C-840
4E-08
660178
220980
220983
25K-30018
221076
206864
100949
209343
201951
1F-432
1C-720
4E-07
221077
221078
221079
941653
551906
SK200-48
Lockwire, Turbine to Hub Shaft, Main Drive Gear Oil Ring, Main Drive Shaft Bearing, Main Drive Gear Retainer Gear, Main Drive (33T) Nut, Main Drive Gear Retainer Shaft, Oil Pump Piston Ring, Oil Pump Shaft Gear, Output Shaft (32T) Spacer, Output Gear Ring, Oil Pump Drive Gear Hub Retainer Bearing, Oil Pump Drive Gear Hub Ring, Oil Pump Driven Gear Hub Brg. Retainer Bearing, Oil Pump Driven Gear Hub Hub, Oil Pump Driven Gear "0" Ring, Oil Cross-Over Tube Tube, Oil Cross-Over "0" Ring, Oil Cross-Over Tube Gear, Oil Pump Driven (43T) Cover, Converter Housing Bearing, Oil Pump Driven Gear Hub Ring, Oil Pump Driven Gear Hub Brg. Retainer Ring, Oil Pump Drive Gear Hub Brg. Retainer Hose, Valve Body to Converter Pump Gasket, Valve Body "0" Ring, Valve Body to Converter Housing Roll Pin, Regulating Valve Body Spring, Regulating Valve, Outer Stop, Regulating Valve Piston "0" Ring, Regulating Valve Stop Spring, Regulating Valve, Inner Body, Regulating Valve (See 123) Bolt, Regulating Valve Body Bolt, Regulating Valve Body Lkwshr, Regulating Valve Body Roll Pin, Regulating Valve Body Piston, Regulating Valve Body Stop, Regulating Valve Body "0" Ring, Regulating Valve Stop Cap, Output Shaft Oil Seal, Output Shaft Deflector, Output Shaft Flange & Deflector Assembly (Inc. Item 85) Nut, Output Shaft Flange Cotter, Flange Nut Bolt, Output Shaft Bearing Cap Lkwshr, Bearing Cap Shim, Output Bearing Cap (.004) Shim, Output Bearing Cap (.007) Shim, Output Bearing Cap (.010) Oil Pump Assembly (Inc. 93) Gasket, Oil Pump Bearing, Oil Pump Drive Gear Hub.
.
N.I. — Not Illustrated
AR — As Required
N.S.S. — Not Sold Separately
PM 1188
[38
]
Req'd
N I AR
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
2
1
3
1
1
1
1
1
1
1
1
1
1
4
4
AR
AR
AR
1
1
1
CLARK
EQUIPMENT
MICHIG1111
MODEL 75 SERIES
No.
Item
No.
Part No.
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
114
111A
111B
111C
112
113
114
115
116
117
118
119
120
121
205096
SK250-130
851240
1C-720
4E-07
209294
221080
221082
220987
851240
SK250-130
221081
SK203-97
209334
SK203-97
221075
SK250-96
SK250-97
SK250-98
SK250-99
SK251-38
220979
207647
659041
89F-8
8D-06
4E-06
221083
800840
800880
122
123
800881
800877
Description
Stud, Oil Pump Mounting Ring, Oil Pump Driven Gear Hub Retainer Bearing, Oil Pump Driven Gear Hub Bolt, Cover to Housing Lkwshr, Cover to Housing "0" Ring, Housing to Cover Sealing Gear, Oil Pump Drive (46T) Gear, Oil Pump Driven (43T) Hub, Oil Pump Driven Gear Bearing, Oil Pump Driven Gear Hub Ring, Oil Pump Driven Gear Hub Brg. Retainer Hub, Oil Pump Drive Gear Bearing, Output Shaft Shaft, Output Bearing, Output Shaft Washer, Main Drive Gear Nut Retainer Ring, Main Drive Gear Bearing (.088-.090) Ring, Main Drive Gear Bearing (.091-.093) Ring, Main Drive Gear Bearing (.094-.096) Ring, Main Drive Gear Bearing (.097-.099) Ring, Main Drive Gear Brg. Retainer Dowel, Housing to Cover Stud, Vehicle Pump Mounting Ring, Oil Pump Shaft Retainer Connector, Hydraulic Tube Nut, Converter Oil Pump Lkwshr, Converter Oil Pump Spacer, Oil Pump Drive Gear Gear Set, Converter Drive & Driven (Inc. Items 1, 3 and 34) Converter Housing and Back Cover Assy.
(Inc. Items 22, 29, 64, 98, 99, 100 and 113) Reaction Member and Race Assy. (Inc. Items 10, 37, 38) Pressure Regulator Valve Assy. (Inc. Items 69 thru 76 and 79 thru 82) Req'd
6
1
1
12
12
1
1
1
1
1
1
1
1
1
1
1
AR
AR
AR
AR
N I1
N I1
N I6
N I1
N I1
N I6
N I 6
N I1
1
1
1
TORQUE CONVERTER MOUNTING PARTS
Item
No.
No.
Part No.
124
125
126
127
1C-624
4E-06
1C-620
4E-06
Description
Bolt, Torque Converter to Flywheel Lkwshr, Torque Converter to Flywheel Bolt, Torque Converter to Flywheel Housing Lkwshr, Torque Converter to Flywheel Housing N.I. — Not Illustrated
AR — As Required
N.S.S. — Not Sold Separately
\ PM 1188
[39
]
Req'd
NI
NI
NI
NI
8
8
12
12
CLARK
EQUIPMENT
foliiill.
.ii_isma
y
"111,10
.\
1
_#,1411,1
.. z
41Mr
rAllimmk
A ll
,,
Alb
\_A
%' AllilL '
V
,igi
1 ikrAl r
1
k NARSIZ7
PM 1188
[ 40 ]
,
Ilika 1.
MICHIG11111
CUIRK
EQUIPMENT
MICHIGAn
AXLE ASSEMBLY—FRONT DRIVE
75A — 8123 and Thereafter
75B6123 and Thereafter
75R7156 and Thereafter
ItemPart
No.No.
Description
No.ItemPart
No.No.
Req'd.
I
Description
25A 106335Brake Assembly — R.H.—See Index
A130064Front Drive Axle Assembly —
1
Complete 106092
26106092
26
Seal, Hub Oil 1 106346Planet Spider Assembly—See Index 2
107608
27107608
27
Clip, Inspection Hole Cover
2 106059Gear, Internal 2
940330
28940330
28
3 106880Bolt, Internal Gear 16
29106793
29
106793
3A
No.
Req'd.
2
2
Lockwire — 18 Gauge 8
Drain & Filler 14 103076 Nut, Wheel Stud & 44)
23 2D-08 Nut, Brake Attaching
2038A 106454Sun Gear Thrust Cap Assy. (Inc. 37
1461C-728f Bolt,Differential Carrier 16
16
48 550406
48
550406 11- Tee, Brake Line 16
16
24 4E-08Lkwshr, Brake Attaching 49 106102
49
106102
25 106336Brake Assembly — L.H.--See Index 1 t --- Not Illustrated
PM 1188
2
[ 41 ]
t Differential & Carrier Assemblyt
See Index 8
11
11
,CLqR14:
EQUIPMENT
PM 1189
[42
]
MICHIGH
CLARK
EQUIPMENT
MICHIGIII1
AXLE ASSEMBLY FRONT STEER
MODEL 75R
Item
Part
No.
No.
A
130148
No.
Description
Req'd.
Front Steering Axle Assy.
(Inc. all following items) 1
1
106158
Hub Assembly — See Index 2
2
106140
Steering Knuckle Assy. — L.H. (Inc. 3 & 4) 1
3
106142
Steering Knuckle — L.H.
1
4
102225
Bushing, Steering Knuckle 4
5
12F-110
Plug, Steering Knuckle Expansion 4
Tie Rod End Assy. — See Index 6
7
106143
Tie Rod Assembly (Inc. 6 & 7A) 1
7A
106144
Tie Rod 1
8
4D-16
Nut, Tie Rod Arm 2
9
1F-628
Cotter, Tie Rod Arm 2
10.
7J-3108
Key, Tie Rod Arm 2
11
106162
Pin, Knuckle 2
12
102252
*Shim, Knuckle 13
106139
Steering Knuckle Assy. — R.H. (Inc.4 &14) 1
1
14
106141
Steering Knuckle — R.H. 15
T-138
Thrust Bearing 16
102250
Key, Draw
2
17
4E-06
Lkwshr, Draw Key 2
18
2D-06
Nut, Draw Key 19
106163
Arm, Tie Rod — R.H.
1
20
106149
Axle Center Assy. (Inc. 21) 1
21
550066
Bushing
2
22
1F-416
Cotter, Tie Rod 2
23
106164
Arm, Tie Rod — L.H.
1
24
10H-25
t Fitting, Tie Rod Grease — As Required
t— Not Illustrated
PM 1188
[ 43 ]
2
0
11 12131518
/{471
0
N
AV3 NIH3 VW
0
In
0
a
AXLE ASSEMBLY - REAR DRIVE AND STEER
C3
3:1
CUIRK
EQUIPMENT
mICHIGAn
AXLE ASSEMBLY — REAR DRIVE AND STEER
MODEL 75A
For Serial 8123 Thru 8609
Part
No.
Item
No.
A 130048
1
2
3
4
5
6
6A
7
8
8A
9
106136
106135
106134
106132
106133
106130
106131
103076
103445
103522
106106
10
11
12
7E-08
100970
940330
13
14
15
15A
15B
15C
16
17
18
18A
19
20
20A
20B
21
22
22A
23
24
25
26
27
28
29
30
31
32
33
33A
106059
106880
106066
1C-808
3E-08
4E-07
1C-720
106183
106068
14F-04
106319
106320
106321
106790
106097
106099
106539
106762
106095
104549
106322
102766
106313
106127
106129
106128
106117
106121
Description
No.
Req'd.
Rear Drive & Steer Axle Ass'y. (Inc.
1
All Following Items) 4
Retainer Ring, Outer End. Seal . .
2
Retainer, Outer End Dust Seal. ...
2
Spring, Outer End Dust Seal 2
Seal, Outer End Oil 2
Seal, Outer End Dust 2
Retainer, Outer End Oil Seal 2
Gasket, Outer End Oil Seal Retainer
20
Nut, Wheel Stud 20
Stud, Wheel Nut, Wheel 20
Hub & Cup Assembly (Inc. 7, 8, 8A,
2
52 & 53) Lkwshr,Planet Spider ..... 20
Bolt, Planet Spider 20
Internal Gear Hub & Screw Kit (Inc.
2
14) 2
Gear, Internal 16
Bolt, Internal Gear Planet Spider — See Index
2
tGasket, Planet Spider tBolt,Puller Hole 4
4
tLkwshr, Puller Hole Bolt Lkwshr, Thrust Cap 12
12
Bolt, Thrust Cap Cap, Sun Gear Thrust 2
Gasket, Sun Gear Thrust Cap.
2
2
Plug, Oil Level — Thrust Cap *Shim, Steering Arm — Thick *Shim, Steering Arm -- Medium.
*Shim, Steering Arm — Thin Arm,Steering.........
2
Steering Spindle Ass'y. (Inc. 22A). .
2
Bushing, Steering Spindle Bolt, Steering Spindle 20
Washer, Steering Spindle 20
Gasket, Steering Spindle 2
Washer, Steering Arm — Inner 2
Bolt, Steering Arm — Inner 2
Washer, Steering Arm — Outer 2
Bolt, Steering Arm — Outer 2
Seal, Universal Joint Shaft
4
Washer, Universal Joint Thrust... .
4
Washer, Oil Seal 2
Housing Outer End 2
Retainer, Steering Trunnion Oil. ...
2
ItemPart
No.No.
No.
Req'd.
34M903310 Cup, Steering Trunnion Bearing . . . .
35M903345 Cone, Steering Trunnion Bearing ..
Steering Trunnion 36106120
FillerPlug 3713F-12
Housing
38106116
Breather
Assembly
39106656
Bolt, Housing Outer End 40106735
40A 4E-10
I- Lkwshr, Housing Outer End 40B2D-10
1- Nut, Housing Outer End Steering Spindle Support Ass'y. —
41106100
R.H. (Inc. 41A & 61) Steering Spindle Support — R.H.. .
41A 106111
Bolt, Outer End 421C-612
42A 4E-06
Lkwshr, Outer End Tie
Rod End Asseembly—See Index
43
Tie
Rod Assembly (Inc. 43 & 44A)
44106108
44A 106109
Tie Rod Plug, Housing Drain 4514F-12
Cotter, Tie Rod 461F-424
47106119
Steering Trunnion — Flanged . . .
Axle Shaft & Universal Joint Ass'y..
48106096
*Shim, Steering Trunnion — Thick.. .
49106123
49A 106124 *Shim, Steering Trunnion — Medium
49B106125 *Shim, Steering Trunnion — Thin .
Seal, Hub Oil 50106092
Cone, Hub Bearing — Inner 5147681
Cup, Hub Bearing — Inner 5247620
Cup, Hub Bearing — Outer 5347820
Cone, Hub Bearing — Outer 5447896
-
55
56100965
57100967
58100966
59106058
602D-09
60A 4E-09
61106115
62106101
62A 106112
6313F-12
64106075
65101004
661C-722
671C-728
684E-07
6912F-204
7010H-25
— As Required
PM 1188
Description
[ 45 ]
Not Applicable This Model
Nut, Steering Spindle — Inner.
Lock, Steering Spindle Nut Nut, Steering Spindle — Outer.
Gear, Sun Nut, Steering Trunnion Lkwshr, Steering Trunnion Stud, Steering Trunnion Steering Spindle Support Ass'y.
L.H. (Inc. 61 & 62A) Steering Spindle Support —L.H...
1- Filler Plug, Spindle Support... .. .
Diff. & Carrier Ass'y. --- See Index.
tGasket, Diff. Carrier
tBolt,Diff.Carrier tBolt,Diff. Carrier tlockwasher,Diff. Carrier f Plug, Housing Expansion 1- Fitting, Tie Rod Grease -
4
4
1
3
1
1
16
16
16
1
1
24
24
1
1
1
2
3
2
2
2
2
2
2
2
2
2
2
12
12
12
1
2
1
1
10
4
14
1
2
101112 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28
iIr Zi■
10,011
. Nrow 1
/
/P/• ' ' i'll;i
,., mr
e i
29
30
31
■
4
11kiii.W
IN
3
A
fil■■
II1,=
Ni1 01M11W
N.LON
I
2
1
■ :1
Nr
.,•
em-=11:74/
vi
_ .am
r 7t i -:70711/4r
4/ •
0
A MIE
ir
70
In
/AL
_Ty
*PIy
/A/
0
PER
ami
69
• Al $1.
68
32
33
34
35
■
67
0
39 -38 -37-36
40-41-42
66
a
6564 63 62 61.60 59 58 57 56 55 54 53 52 51 50-49 48 47 46 45 44 43
TS I36
-
CUIRK
EQUIPMENT
MICHIGIIII
AXLE ASSEMBLY REAR DRIVE STEER
MODEL 75A
Effective with Serial 8610 and Thereafter
ItemPart
No.No.
Description
No.
Req'd.
ItemPart
No.No.
No.
Req'd.
Omit 34
16
35 106998Nut, Outer End 36 106130Retainer, Outer End Oil Seal 2
37 106131 Gasket, Outer End Oil Seal Retainer 2
38 106132Seal, Outer End Oil 2
39 106133Seal, Outer End Dust 2
40 106134 Spring, Outer End Dust Seal 2
41106135Retainer, Outer End Dust Seal. 2
42 106136Ring, Outer End Seal Retainer 4
43 4E-09Lkwshr, Steering Trunnion Stud . 12
44 2D-09 Nut, Steering Trunnion Stud 12
45 106115Stud, Steering Trunnion 12
46 106119Steering Trunnion — Flanged . 3
47 106100 Steering Spindle Support Ass'y. —
1
R.H. (Inc. 45 & 47B) 47A 106101 Steering Spindle Support Ass'y —
L.H. (Inc. 45 & 47C) 47B 106111Steering Spindle Support — R.H. . 47C 106112Steering Spindle Support — L.H. . 48 106123 *Shim, Steering Trunnion — Thick 49 106124 *Shim, Steering Trunnion — Medium
50 106125 *Shim, Steering Trunnion — Thin 2
51 106092Seal, Hub Oil 2
52 106820Oil Slinger 53 106816Brake Disc Assembly See Index. 2
54 106099Bushing, Steering Spindle 2
55 106096 Axle Shaft & Universal Joint Ass'y 2
12
56 107256Bolt, Brake Drum 57 104412Washer, Brake Drum 12
2
58 106879Hub, Internal Gear 59 106821Steering Spindle Ass'y. (Inc. 54). . . 2
60 106814Hub & Drum Ass'y. (Inc. 15, 60A &
2
61) 2
60A
100320 tClip, Inspection Hole 2
Hub & Cup Ass'y. (Inc. 9 & 13).
106793
61
2
Lock, Steering Spindle Nut 62
100967
2
Nut, Steering Spindle — Outer.
100966
63
2
Plug, Wheel Hub Filler 13F-12
64
2
Gasket, Sun Gear Thrust Cap 65
106068
12
Lkwshr, Thrust Cap 4E-07
66
12
Bolt, Thrust Cap 1C-720
67
2
Sun Gear 68
106058
2
Cap, Sun Gear Thrust 69
106183
2
Plug, Oil Level 14F-4
70
1
*Plug, Housing Filler
13F-12
71
1
*Plug, Housing Drain
14F-12
72
12F-204 tPlug, Housing Expansion 1
73
1
106656 I-Breather
74
1
101004 tGasket, Differential Carrier
75
t Bolt, Differential Carrier
6
1C-722
76
8
1C-728
77
t Bolt, Differential Carrier
tl-kwshr, Differential Carrier 14
4E-07
78
1
106116 f Housing, Differential Carrier
79
Differential & Carrier Ass'y. —
106075
80
1
See Index A 130049Rear Drive & Steer Axle Assembly
1
(Inc. all following Items)
Planet Spider Assembly—See Index 2
1
4
1A 1C-808Bolt, Puller Hole 1B 3E-08Lkwshr, Puller Hole Bolt 4
2
2 106059Gear, Internal 16
3 106880Bolt, Internal Geqr 3A Lockwire — 18 Gauge 8
20
4 100970Bolt, Planet Spider 5 7E-08 Lkwshr, Planet Spider 20
2
6 106066Gasket, Planet Spider 7 100965Nut, Steering Spindle — Inner.. 2
8 47896 Cone, Hub Bearing — Outer 2
9 47820Cup, Bearing — Outer 2
20
10 103445 Stud, Wheel 20
11 103522Nut, Wheel 20
12 103076Nut, Wheel Stud 13 47620Cup, Bearing — Inner 2
14 47681Cone, Hub Bearing — Inner 2
2
15 106815Brake Drum 20
Washer,
Steering
Spindle
16 106762 17 106539Bolt, Steering Spindle 20
17A Lockwire, Spindle Bolt — 18 Gauge 10
18 106095Gasket, Steering Spindle 2
19 102766 Washer, Steering Arm Bolt — Outer 2
19A 104549Washer, Steering Arm Bolt — Inner 2
20 106313Bolt, Steering Arm — Outer 2
20A 106322 Bolt, Steering Arm — Inner 2
20B Lockwire, Steering Arm Bolt -2
18 Gauge 21106121Retainer, Steering Trunnion Oil... 2
1
22 106120Steering Trunnion
23 M903345 Cone, Steering Trunnion Bearing.. 4
24 M903310 Cup, Steering Trunnion Bearing 4
24
25 4E-06Lkwshr, Outer End 24
26 1C-612Bolt, Outer End 2
27 106117Housing, Outer End 27A 13F-12 Filler Plug, Outer End Housing ..2
1
28 106790 Steering Arm 28A 106319 *Shim, Steering Arm — Thick
28B 106320 *Shim, Steering Arm — Medium
28C 106321 *Shim, Steering Arm — Thin Washer, Universal Joint Thrust.. • . 4
29 106129
Oil Seal, Universal Joint Shaft.. • . 4
30 1061 27
2
Washer,
Oil Seal
31 106128
Tie Rod End Assembly—See Index 2
32
1
32A 106109 tTie Rod 32B 106108 tTie Rod Assembly (Inc. 32 & 32A). 1
2
tCotter, Tie Rod End 32C 1F-424
32D 10H-25 tFitting, Tie Rod End Grease 2
16
Bolt, Outer End 33 106735
.
— As Required
PM 1188
Description
[47
]
0
z
4n
;04
0
0
z
a
AXLE ASSEMBLY REAR STEERING
CUIRK
EQUIPMENT
MICHIG1111
MODEL 75B
For Serial6123 thru 6127, 6129 thru 6133, 6135 thru
6138, 6140 thru 6143, 6146, 6147, 6148, 6150, 6153, 6154,
6156, 6160, 6161, 6164, 6166, 6169, 6170, 6176 and 6179
Item
No.
A
1
2
3
4
5
6
7
8
9
10
11
12
13
13A
13B
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
Part
No.
* 130144
100323
1 F-428
100575
100588
25821
25877
SK250-27
100857
1F-416
106167
103166
103227
106165
15H-1
106166
103165
2C-836
103953
103954
2D-08
4E-08
12F-200
103929
B-2420
103228
11D-08
T-151
2D-06
4E-06
102594
13G-820
103927
103942
11H-1
103917
1C-1048
4E-10
103928
106160
Description
Rear Steering Axle Assembly (Inc. all following items) Cap, Spider Hub Grease Cotter, Spider Nut Nut, Spider Washer, Spider Bearing Cup, Spider Bearing Cone, Spider Snap Ring, Spider Bearing Omit
Nut, Tie Rod End Cotter, Tie Rod End Ball Bolt Steering Spider Cover, Tie Rod End Ball Tie Rod End Assy. — L.H. (Inc. 9 & 12) Tie Rod Assy. (Inc. 9, 12 thru 16, 19, 20 & 24) Fitting, Tie Rod End Grease Tie Rod Clamp, Tie Rod Bolt, Tie Rod Clamp Felt, Spider Hub Cup, Spider Hub Felt Nut, Tie Rod Clamp Bolt Lkwshr, Tie Rod Clamp Bolt Plug, Axle Center Expansion Knuckle Pin Bearing, Steering Knuckle Pin Tie Rod End Assy. — R.H. (Inc. 9 & 12) Nut, Knuckle Stop Screw Bearing, Knuckle Thrust Nut, Knuckle Pin Draw Key •
Lkwshr, Knuckle Pin Draw Key Key, Knuckle Pin Draw Screw, Knuckle Stop Steering Knuckle — R.H. *Shim, Knuckle Fitting, Knuckle Pin Grease Axle Center Assy. (Inc. 23, 35 & 36) Bolt, Axle Center Bearing Mtg. Cap Lkwshr, Axle Center Brg. Mtg. Cap Steering Knuckle — L.H Hub Assembly — See Index
* Kit #107609 is available to convert #130144 Axle to
new style #130151 Axle. When #107609 is installed,
use #130151 list for replacement Parts.
— As Required
PM 1188
(49
1
No.
Req'd.
1
1
1
1
1
2
2
2
4
4
1
4
2
2
4
2
4
4
1
1
4
4
4
2
4
2
2
2
4
4
4
2
1
4
1
8
8
1516
3837 36 35 34 33 3231
AXLE ASSEMBLY — REAR STEERING
17181920
CUIRK
EQUIPMENT
mlCHICAn
MODEL 75B
For Serial
6128, 6134, 6139, 6144, 6145, 6149, 6151,
6152, 6155, 6157, 6158, 6159, 6162, 6163, 6165, 6167,
6168, 6171 thru 6175, 6177, 6178, 6180 & Thereafter
Item
No.
Part
No.
A
Description
No.
Req'd.
130151Rear Steering Axle Assembly (Inc.
all following items) 1
Wheel & Rim Assy. — See Index
2
103928 Steering Knuckle — L.H.
1
2A 103927Steering Knuckle — R.H . 1
2B 13G-820 tScrew, Knuckle Stop 2
2C 7D-08
1- Nut, Knuckle*Stop Screw 2
3
T-151
Bearing, Knuckle Thrust 2
4
B-2420
Bearing, Knuckle Pin 4
5
12F-200
Expansion Plug, Axle Center 4
6
103929
Pin,Knuckle
2
7
103227
Tie Rod End Assembly — L.H. (Inc.
8 & 30) 7A 106165
2
Item
No.
Part
No.
Description
No.
Req'd.
22
25821
Cup, Spider Bearing — Upper 1
23
26822
Cup, Spider Bearing — Lower .. . 1
24
26882
Cone, Spider Bearing — Lower .
1
25
107461
Seal, Spider 1
26
107449
Pin, Steering Arm 1
27
4E-10
Lkwshr, Axle Center Brg. Mtg. Cap .
8
28
1C-1048
Bolt, Axle Center Brg. Mtg. Cap.. 8
29
650737
Pin, Steering Arm Pin Lock 1
30
100857
Nut, Tie Rod End Ball Bolt 4
Cotter, Tie Rod End Ball Bolt 4
30A 1F-416
31
103942
32
11H-1
Fitting, Knuckle Pin Grease 4
33
2D-06
Nut, Knuckle Pin Draw Key 4
tShim, Knuckle Tie Rod Assembly (Inc. Items 7, 8,
10 thru 13, 15 & 30) 2
33A 4E-06
Lkwshr, Knuckle Pin Draw Key 4
8
103166
Cover, Tie Rod End Ball 4
34
102594
Draw Key, Knuckle Pin 4
9
15H-1
Fitting, Tie Rod End Grease 4
35
103935
Seal, Inner Hub Oil 2
10
103165
Clamp, Tie Rod 4
36
559
Cone, Inner Hub Bearing 2
11
2D-08
Nut, Tie Rod Clamp Bolt 4
37
552A
Cup, Inner Hub Bearing 2
12
2C-836
Bolt, Tie Rod Clamp 4
38
106160
Hub Assembly (Inc. 37, 38A, 39 &
12A 4E-08
Lkwshr, Tie Rod Clamp Bolt 4
13
106166
Tie Rod 2
14
107447
Axle Center Assembly (Inc. 4 & 26
thru 29) 2
44 thru 49) 38A 106342
Hub 2
39
26822
Cup, Outer Hub Bearing 2
40
26882
Cone, Outer Hub Bearing 2
41
102251
Washer, Knuckle 2
42
4D-20
Nut, Knuckle 2
43
1F-632
Cotter, Knuckle 2
2
15
103228
Tie Rod End Assembly — R.H.
(Inc. 8 & 30) 16
107451
Steering Spider 16A 107450
Steering Spider & Cup Assy.
(Inc. 22 & 23) 1
44
103188
Cap, Hub Grease .
2
17
100323
Cap, Spider Hub Grease 1
45
6E-06
Lkwshr, Hub Grease Cap 10
18
100575
Nut, Spider 1
46
1C-614
Bolt, Hub Grease Cap 10
19
1F-428
Cotter, Spider Nut 1
47
103522
Nut, Wheel Cap 12
20
100588
Washer, Spider 1
48
103445
Stud, Wheel Mount 12
21
25877
Cone, Spider Bearing — Upper 49
103076
Nut, Wheel Stud 12
— As Required
PM 1188
[ 51
0
z
0
z
ht
In
0
a
r3
r3
CUIRK
EQUIPMENT
MICHIG1111
AXLE ASSEMBLY REAR DRIVE
MODEL 75R
For Serial 7123 thru 7155
ItemPart
No.No.
A
130056
Description
Axle Ass'y. — Rear Drive (Inc. All
Following Items)
1
1C-720
Bolt, Thrust Cap 2
4E-07
Lkwshr, Thrust Cap 3
106454
Sun Gear Thrust Cap Ass'y. (Inc. 4
Part
No.
Description
No.
Req'd.
21
106058
Gear, Sun 2
22
SK251-23
Snap Ring, Sun Gear 2
12
23
106092
Seal, Hub Oil 2
12
24
2D-08
Nut, Brake Attaching 16
25
4E-08
Lkwshr, Brake Attaching
16
26
101092
Bolt, Brake Attaching 27
47681
103076
Nut, Wheel Stud 29
47620
30
47820
Cup, Hub Bearing — Outer
2
31
103445
Stud, Wheel 20
Nut, Wheel 20
2
& 5) 16
2
4
106067
Cap, Sun Gear Thrust 5
106455
Washer, Sun Gear Thrust Cap. 2
6
106068
Gasket
2
20
2
Planet Spider Ass'y. — See Index 2
7
8
100970
Bolt, Spider 20
9
7E-Q8
Lkwshr, Spider 20
106343
Hub & Drum Assembly (Inc. 11 thru
10
Item
No.
No.
Req'd.
12D & 28 thru 31A) 31A 103522
2
32
47896
Cone, Hub Bearing — Outer 33
940330
Internal Gear Hub & Screw Kit
11
106793
Hub & Cup Assembly (Inc. 29 & 30) 2
12
106344
Drum, Brake 2
12A 107256 Bolt, Brake Drum 12
12B 104412Washer, Brake Drum 12
12C 101597Oil Throw 2
12D 107608Clip, Inspection Hole Cover 2
(Inc.35) 2
2
34
106059
Gear, Internal 35
106880
Bolt, Internal Gear 36
2
16
Omit 37
100965
Nut, Housing Tube — Inner 2
13106336
Brake Assembly — L.H. 1
38
100967
Lock, Housing Tube Nut 2
13A 106335
Brake Assembly — R.H.
1
39
100966
Nut, Housing Tube — Outer 2
14
106066
Gasket, Spider 2
40
1C-808
tBolt,Puller Hole 4
15
101004
Gasket, Differential Carrier
1
41
3E-08
-
1- Lkwshr, Puller Hole Bolt 4
16
106656
Breather Assembly 1
42
106075
17
106082
Axle Housing Ass'y. (Inc. 16 thru
17A & 37 thru 39) 17A 105111Housing, Axle 18
14F-12
Plug, Housing Drain
19
13F-12
Plug, Housing Filler 20
106087
Shaft, Axle See Index Planet Spider Ass'y. — See Index.
2
1C-722
tBolt,Differential Carrier 6
45
1C-728
"[Bolt,Differential Carrier 8
1.
46
4E-07
fl.kwshr, Differential Carrier 14
2
47
550406
1
43
1
44
1
PM 1188
Differential & Carrier Ass'y. —
[
53]
Tee, Brake Line 1
CUIRK
EQUIPMENT
MICHIGAN
HUB ASSEMBLY
MODEL 75B
Item
No.
Part
No.
A
106160
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
103935
559
552A
106342
103445
26822
26882
4D-20
103188
1C-614
6E-06
1F-632
102251
103522
103076
PM 1188
Description
MODEL 75R
No.
Req'd.
Hub Assembly (Inc. 3 thru 6, 10 thru
12, 15 & 16) Seal, Inner Hub Oil Cone, Inner Hub Bearing Cup, Inner Hub Bearing Hub Stud, Wheel Mount Cup, Outer Hub Bearing Cone, Outer Hub Bearing Nut, Knuckle Not Applicable This Model
Cap, Hub Grease Bolt, Hub Grease Cap Lkwshr, Hub Grease Cap Cotter, Knuckle Washer, Knuckle Nut, Wheel Cap Nut, Wheel Stud ItemPart
No.No.
2
2
2
2
2
12
2
2
2
2
10
10
2
2
12
12
No.
Req'd.
B106158
Hub Assembly (Inc. 3 thru 6, 15 &
16) 2
1102157
Seal, Hub Oil — Inner 2
2539
3532X
4102156
Hub 5103445
Stud, Wheel 63328
Cup, Hub Bearing — Outer 2
73386
Cone, Hub Bearing Outer 2
84D-20
Nut, Knuckle 2
9102159
Cap, Hub Grease 2
10thru12
[ 54 ]
Description
2
12
Not Applicable This Model
131F-632
Cotter, Knuckle 2
141 az251
Washer, Knuckle 2
15103522
Nut, Wheel 12
16103076
Nut, Stud
12
CUIRK
EQUIPMENT
m ICHIGAn
TS- 59- P
PLANET SPIDER ASSEMBLY
ItemPart
No.No.
Description
Item
No.
No.
Req'd.
Planet Spider Assembly
(Inc. all of following items) 2
1106350
Pinion Thrust Washer 12
2106349
Pinion Shaft 6
3106352
Roller Spacer 6
106346
PM 1188
[ 55 ]
Part
No.
Description No.
Req'd.
4
106348
Planet Pinion 6
5
106347
Planet Spider 2
6
106351
Pinion Roller 7
10J-12
Pinion Shaft Ball 348
6
0
z
4445
0
z
43
42 41
40 39
36- .
z
3534
33
1920
0
2592-P-43-54
3130
DIFFERENTIAL AND CARRIER ASSEMBLY
CLeiRK
EQUIPMENT
mICHIGAn
DIFFERENTIAL AND CARRIER ASSEMBLY
ItemPart
No.No.
Description
ItemPart
No.No.
No.
Req'd.
A * 106102 Differential & Carrier Ass'y. —
Front Drive
*106075Differential & Carrier Ass'y. —
Rear Drive
1
*(The Above Assemblies Inc. 1 thru 34 & 37 thru 52)
No.
Req'd.
29 100943
Gasket, Pinion Oil Seal Retainer 1
30 53375
Cup, Pinion Outer Bearing
1
§ Cage, Outer Pinion Bearing
(See 48)
1
31
1
Description
32 55187
Cone, Pinion Center Bearing . 1
UC-1306TAM Bearing, Pinion Inner
1
1100937Bolt, Diff. Carrier Cap Mtg 4
33
2 102766Washer, Diff. Carrier Cap Mtg.. 4
34 100946
*Shim, Bearing Cage — Thin
3
Cap, Diff Carrier (See 49) 2
34A 100947
*Shim, Bearing Cage — Medium .
1
34B 100948
*Shim, Bearing Cage — Thick
5 100941Lock, Diff. Adjusting Nut 2
35 1C-722
Bolt, Carrier to Axle Housing. . 6
6 100173Washer, Thrust— Diff. Side Gear 2
35A 1C-728
Bolt, Carrier to Axle Housing .
7 100176 Bolt, Ring Gear 36 4E-07
Lkwshr, Carrier to Axle Housing 14
37
Diff. Carrier (See 49)
4100171Spider, Diff.
8
12
Diff. Case — Flanged Half (See
53)
8
1
1
38
100169Pinion, Diff 8
39
Washer, Diff. Pinion Thrust 100172
10 21D-08Nut, Ring Gear Bolt 12
40
100170
9 100174Bolt, Diff. Case 4
2
Gear, Side — Diff
1
41
Plain Half — Diff. Case (See 53) 1
1
42 21D-08
Nut, Diff. Case Bolt
8
13 100954Lock, Diff. Thrust Screw Nut. 1
43 33462
Cup, Diff. Bearing
2
14 100953 Screw, Diff. Thrust
44 100940
Nut, Diff. Adjusting
2
1
1
16 55443Cup, Pinion Center Bearing .
45 33281
Cone, Diff. Bearing 46 4E-06
17 100952Spacer, Pinion Bearing 1
18 53178Cone, Pinion Outer Bearing ... 1
47 204432
Lkwshr, Diff. Adj. Nut Lock 2
2
Bolt, Diff. Adj. Nut Lock
11
Gear, Ring (See 52)
4
12 8D-14Nut, Diff. Thrust Screw
15
1
Pinion (See 52)
19 100944 Seal, Pinion Oil
1
23 100951Washer, Pinion Shaft. 1
24 1 F-428Cotter, Pinion Shaft
1
25 100950Nut, Pinion Shaft 1
26 1C-928Bolt, Pinion Oil Seal Retainer
5
26A 1C-828 Bolt, Pinion Oil Seal Retainer
Locating
1
Diff. Body Sub Assy. (Inc. 4, 6,
8, 9, 10 & 38 thru 41) 51
Differential Assembly (Inc. 7, 11,
15, 42 & 50) 106103
Front Drive
106076
Rear Drive
53 815203
— As Required
50 100160
Ring Gear & Pinion Set (Inc. 11
& 15)
1
815204Rear Drive
1
§ -- Not Sold Separately
PM 1188
Diff. Carrier & Cap Assy. (Inc 2, 3 & 37) 815202Front Drive
27A 4E-08 Lkwshr, Pinion Oil Seal Retainer
28 100942 Retainer, Pinion Oil Seal
49 106042
52
1
27 4E-09Lkwshr, Pinion Oil Seal Retainer 5
Locating
Bearing Cage & Cup Assy. (Inc 30 & 31) 1
20 100945Gasket, Pinion Oil Seal 1
21100949Shield, Pinion Dust
1
22 106081Flange, Companion 48 100938
2
[57 )
Diff. Case Kit (Inc. Items 8 & 41) 1
CLeiRK
CONSTRUCTION
EQUIPMENT
MACHINERY
DIVISION
MICHIGH
GEAR SHIFT LEVERS AND LINKAGE
Item
No.
Part
No.
Description
No.
Req'd.
Item
No.
Part
No.
Description
No.
Req'd.
1
2D-04
Nut, Speed Selector Shift Lever....
1
15
550675
Ball Socket 1
2
4E-04
Lkwshr, Speed Selector Shift Lever.
1
16
8D-06
Nut, Ball Socket 2
3
550803
Lever, Speed Selector Shift 17
4E-06
Lkwshr, Ball Socket 2
4
2C-424
Bolt, Speed Selector Shift Lever.
18
550675
Ball Socket 1
Nut, Ball Socket 2
5
550675
Ball Socket 19
8D-06
6
4E-06
550674
Rod, Shift 2
7
8D-06
Nut, Ball Socket 21
8D-06
Nut, Ball Socket 2
8
550672
U-Bolt, Steering Column 2
22
550675
Ball Socket 1
9
550129
Support, Shift Levers .......
2
23
4E-06
10
550667
High & Low Lever Assembly 1
24
8D-06
Nut, Ball Socket 1
11
300208
Knob, Levers 2
25
2D-04
Nut, Speed Selector Shift Lever.
1
12
550663
Forward & Reverse Lever Assembly.
26
4E-04
Lkwshr, Speed Selector Shift Lever.
1
13
18D-05
Nut, U-Bolt 4
27
550803
Lever, Speed Selector Shift 1
14
550669
Plate Assembly, Shift Lever Support.
2
28
2C-424
Bolt, Speed Selector Shift Lever 1
PM 1188
[ 58 ]
CUIRK
EQUIPMENT
MICHIGAll
TRANSMISSION CONTROL LEVERS AND LINKAGE
MODEL 75A
Item
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
Part
No.
4E-06
550675
8D-06
550691
8D-06
4E-06
550675
2D-10
4E-10
550679
4F-08127
2C-868
616796
550646
551373
300208
550677
12H-15
1F-414
300208
550685
12H 15
-
551373
550646
616796
4E-08
2D-08
Description
Lkwshr, Ball Socket Ball Socket Nut, Ball Socket Rod, Crank to Transmission Nut, Ball Socket Lkwshr, Ball Socket BallSocket Nut, Bell Crank Mtg . Lkwshr, Bell Crank Mtg. Shift Rod Assembly Pin, Shift Rod to Lever Bolt, Lever Mtg . Washer, Lever Mtg. Sleeve, Lever Mtg . Bushing, Lever Mtg. Knob, Range Lever Range Lever Assembly (Inc. 15).
Fitting, Range Lever Grease Cotter, Clevis Pin Knob, 4WD Lever Lever Assembly, 4WD (Inc. 23).
Fitting, 4WD Lever Grease Bushing, Lever .Mtg. Sleeve, Lever Mtg . Washer, Lever Mtg. Lkwshr, Lever Mtg . Nut, Lever Mtg . t — Not Illustrated
PM 1188
Item
No.
No.
Req'd.
1
1
2
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
1
[59 1
Part
No.
4F-08127
550687
1F-414
4F-08127
551373
551496
551497
551494
12H-15
4F-08127
4J-8300
8D-08
550683
1F-310
4F-06106
8D-06
551373
550646
550689
12H-15
4E-06
550675
1F-414
4C-844
2D-08
4E-08
616796
Description No.
Req'd.
Pin, Shift Rod to 4WD Lever Clevis.
Shift Rod Assembly Cotter, Clevis Pin Pin, Shift Rod to Bell Crank Clevis.
Bushing, Bell Crank Mtg..... .. ...
Sleeve, Bell Crank Mtg. Bolt, Bell Crank Mtg. Bell Crank Assembly (Inc. 32) Fitting, Bell Crank Grease Pin, Yoke to Bell Crank Clevis Yoke, Shift Rod to Bell Crank Nut, Yoke Jam Shift Rod Assembly Cotter, Clevis Pin Pin, Shift Rod to Crank Clevis Nut, Ball Socket Bushing, Crank Mtg. Sleeve, Crank Mtg . Crank Assembly (Inc. 44) Fitting, Crank Grease Lkwshr, Ball Socket Ball Socket Cotter, Clevis Pin 1- Bolt, Crank Mtg. tNut, Crank Mtg . tLkwshr, Crank Mtg . Washer, Crank Mtg. -
-
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
CLARK
EQUIPMENT
CONSTRUCTION
MACHINERY DIVISION
MICHIGIII1
20
TRANSMISSION CONTROL LEVER AND LINKAGE
MODEL 75B AND 75R
Item
No.
1
2
3
4
5
6
7
8
9
10
11
Part
No.
4F-08127
2C-844
616796
550646
551373
300208
550677
12H-15
4E-08
2D-08
1F-414
PM 1188
Description
No.
Req'd.
Pin, Clevis Bolt, Lever Mtg
Washer, Lever Mtg
Sleeve, Lever Mtg. Bushing, Lever & Bell Crank Mtg..
Knob, Range Lever Range Lever Assembly (Inc 5) Fitting, Range Lever Grease Lkwshr, Lever Mtg. Nut, Lever Mtg. Cotter, Clevis Pin . .
I
3
1
1
1
3
1
1
2
1
1
3
[ 60
Item
No.
12
13
14
15
16
17
18
19
20
21
22
Part
No.
550679
551496
551497
551494
4J-8300
8D-08
550683
1F-310
4F-06106
2D-10
4E-10
Description
No.
Req'd.
Shift Rod Assembly Sleeve, Bell Crank Mtg Bolt, Bell Crank Mtg. Bell Crank Assembly (Inc. 5) Yoke, Shift Rod to Bell Crank Nut, Yoke Jam Shift Rod Assembly Cotter, Clevis Pin Pin, Clevis Nut, Bell Crank Mtg Lkwshr, Bell Crank Mtg 1
1
1
1
1
1
1
1
1
1
CUIRK
EQUIPMENT
MICHIGAll
PROPELLER SHAFT ASSEMBLY
Item
No.
Part
No.
A
550579
1943221
1A 940076
2
10H-25
3 940085
4 940080
5
6 940082
7 10H-25
8
9 695811
9A 940078
10 940081
B
1
lA
2
3
4
5
6
514268
943221
940076
10H-25
942659
940654
940653
943222
Description
Item
No.
No.
Req'd.
Propeller Shaft Assembly, Engine to
Trans.
For Serial:
75A — 8123 thru 10222, 10240 &
10247 thru 10251 75B — 6123 thru 6200 75R — 7123 thru 7154 Spider & Bearing Assembly (Inc. 1A) 2
8
Cork Washer 2
Fitting, Spider & Bearing Grease..
1
Stub Yoke 1
Retainer, Felt Omit
Slip Yoke Assembly Fitting, Slip Yoke Grease Omit
16
Bolt tLkwshr, 16
1
Felt Washer Propeller Shaft Assembly, Engine to
Trans.
75A — 10223 thru 10239, 10241
75B — 6201 & thereafter. . ......
75R — 7155 & thereafter Spider & Bearing Assembly (Inc. 1A)
Cork Washer Fitting, Spider & Bearing Grease. .
Stub Yoke Retainer, Felt Washer, Felt Retainer Slip Yoke Assembly .
1
1
1
2
8
2
2
1
[61
]
Description
No.
Req'd.
1
710H-25
8
9695811
9A 940078
10 940081
Fitting, Slip Yoke Grease Omit
Bolt tLkwshr Felt Washer C
550580
Propeller Shaft Assembly, Trans. to
Axles
75A 75B 1
lA
2
3
4
5
6
7
8
9
10
941572
940249
10H-25
940084
940090
940091
942660
10H-25
940088
940089
940092
Spider & Bearing Assembly (Inc. 1A) 2
8
Cork Washer 2
Fitting, Spider & Bearing Grease Tube Assembly Retainer, Felt 2
Washer, Felt Retainer Slip Yoke Assembly Fitting, Slip Yoke Grease...
16
Nut 16
Bolt Washer, Felt D
550778
Propeller Shaft Assembly, Trans. to
Axle — 75R 1
Spider & Bearing Assembly (Inc. 1A) 2
Cork Washer 8
2
Fitting, Spider & Bearing Grease.
1
Tube Assembly 1
Retainer, Felt Washer, Felt Retainer 2
1
Slip Yoke Assembly 1
Fitting, Slip Yoke Grease ... .. . .
Nut 16
Bolt 16
1
Felt Washer 1
941572
1A 940249
2
10H-25
3 940230
4 940090
5 940091
6 942660
7 10H-25
8 940088
9 940089
10 940092
PM 1188
Part
No.
16
16
1
.....
CLeIRK
MICHIGH
EQUIPMENT
HYDRAULIC SYSTEM TRANSMISSION AND TORQUE CONVERTER
For Serial:
75A — 8123 thru 10222, 10240 & 10247 thru 10251
75B6123 thru 6200
75R7123 thru 7154
Item
No.
Part
No.
1
2
3
4
5
6
7
8
9
10
11
552296
6H-16
2C-612
2D-06
4E-06
551996
2C-620
2D-06
4E-06
83F-6
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
712750
550875
551873
83F-6
83F-7
550866
550758
13F-04
30E-1
550758
5K-207
28F-1
550874
31F-2
36F-5
27
28
550724
551896
Description No.
Req'd.
ItemPart
No.No.
Radiator — See Index ..........
Hose, Cooler Lines to Radiator ....
2
1
Clip, Cooler Line to Bracket 1
Bolt, Clip to Bracket 1
Nut, Clip to Bracket 1
Lkwshr, Clip to Bracket 2
Bracket, Clip to Frame 2
Bolt, Bracket to Frame 2
Nut, Bracket to Frame Lkwshr, Bracket to Frame 2
Elbow,Torque Cony. to Overflow
1
Line 1
Hose, Torque Conv. to Trans. 1
Hose, Trans. Clutch Overflow Line Assembly 1
Elbow, Overflow Line to Trans:....
1
Elbow, Cooler Return Line to Trans.
1
Special Cross, Trans 1
Hose, Trans. Clutch 1
1
Pipe Plug, Tee Tee, Trans. — 1/4" 1
Hose, Trans. Clutch 1
Close Nipple, Trans. Clutch Tee..
2
Tee, Trans. Clutch ........
2
Hose, Trans. Clutch.. ....
Adaptor Union, Trans. Clutch Adaptor Union, Trans. to Torque
Cony 1
Hose, Trans. to Torque Cony 1
Special Tee 1
29551323
30550873
30A 553324
3126F-5
3231F-4
32A 31F-5
33*552191
34 *552290
35552473
362C-514
372D-05
384E-05
3989F-7
40552470
40A 957577
4184F-7
42552474
436H-16
442C-612
452D-06
464E-06
No.
Req'd.
Temperature Sender Unit Hose -- For Units with 1/2" P.T Hose — For Units with 3/4" P.T.... .
Elbow, Torque Cony. Adaptor Union — 1/2"-90° —
For Units With 1/2" P.T. Adaptor Union — /4"-90° —
For Units With 3/4" P.T. Cooler Return Line Assembly, Filter
to Trans. Cooler Line Assembly Bracket, Filter.......
Bolt, Filter to Bracket Nut, Filter to. Bracket Lkwshr, Filter to Bracket Connector, Tube_– 37° Flare Filter,Oil Cartridge Kit Elbow, Rad. to Filter Cooler Return Line, Rad. to Filter..
Clip, Cooler Return Line to Bracket.
Bolt, Clip to Bracket Nut, Clip to Bracket Lkwshr, Clip to Bracket 1
1
1
1
1
. 3
1
1
1
1
4
4
4
1
1
1
1
1
1
1
1
1
*For Machines not equipped with Filter, Items 33 and
34 are as follows:
33551872
34551876
34A 89F-7
PM 1188
Description
[
62
Cooler Return Line Assembly Cooler Line Assembly Konnector, Tube — At Radiator...
1
1
CLARK
EQUIPMENT
mICHIcan
HYDRAULIC SYSTEM TRANSMISSION AND TORQUE CONVERTER
75A — 10223 thru 10249, 10241 thru 10246, 10252 & thereafter
75B — 6201 & Thereafter
75R7155 & Thereafter
Item
No.
Part
No.
1
2552296
36H-16
42C-612
52D-06
64E-06
7551996
7A 2C-620
7B 2D-06
7C 4E-06
8552290
985F-8
10712170
11550875
12514613
1383F-7
14550866
15550758
1683F-8
1713F-04
1830E-1
1928F-1
20550758
2131F-2
225K-207
2328F-1
24550874
2531F-2
Description ItemPart
No.No.
No.
Req'd.
Radiator — See Index Hose, Cooler Lines to Radiator Clip, Cooler Line to Bracket Bolt, Clip to Bracket Nut, Clip to Bracket Lkwshr, Clip to Bracket Bracket, Clip to Frame tBolt, Bracket to Frame tNut, Bracket to Frame tLkwshr, Bracket to Frame Cooler Line Assembly— Torque
Cony. to Rad. Elbow, Torque Cony. to Overflow
Line Hose, Torque Cony. to Trans. Hose, Trans. to Torq. Corm Overflow Line Assembly Elbow, Cooler Line to Trans. Special Cross, Trans. Hose, Trans. Elbow, Overflow Line to Trans..
Plug, Pipe — Trans. Tee Tee, Trans. — 1/4" Tee, Trans. Clutch — 1/4" Hose, Trans. Clutch Adaptor Union, Trans. Clutch Close Nipple, Trans. Clutch Tee.
Tee, Trans. Clutch Hose, Trans. Adaptor Union, Trans. Clutch 2697F-20
2
1
1
1
1
1
1
1
1
2736F-6
2836F-5
29552156
30550724
31551896
3226F-5
3326F-6
34514614
35552473
362C-514
372D-05
384E-05
3989F-7
40552470
40A 957577
4184F-7
42552474
436H-16
442C-612
452D-06
464E-06
47551996
47A 2C-620
47B 2D-06
47C 4E-06
48551323
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
PM 1188
[
63
Description No.
Req'd.
Bushing,PipeReducing — 1" to
11/4"
Adaptor Union, Trans. to Torque
Cony. Adaptor Union, Torque Cony. to
Trans. Hose, Trans. to Torque Cony. Hose, Torque Corm to Trans. Tee,Special Elbow, Street — 3/4" Elbow, Trans. to Torque Cony. Pump
Cooler Line Assy., Filter to Trans Bracket, Filter Bolt,Filter to Bracket Nut,Filter to Bracket Lkwshr, Filter to Bracket Flare Tube Connector 37° Filter, Oil tCartridge Kit Elbow, Cooler Return Line to Filter Cooler Return Line — Rad. to Filter
Clip, Cooler Return Line to Bracket Bolt, Clip to Bracket Nut, Clip to Bracket Lkwshr, Clip to Bracket Bracket, Cooler Return Line -I- Bolt, Bracket to Frame tNut, Bracket to Frame tLkwshr, Bracket to Frame -I- Sender Unit, Torque Converter Temp.
1
1
1
1
1
1
1
1
1
1
4
4
4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
CUIRK
EQUIPMENT
PM 1188
[64
]
MICHIGH
CUMK
EQUIPMENT
MICHIGAll
STEERING GEAR ASSEMBLY
ItemPart
No.No.
A
940109
Description Description
No.
Req'd.
695930
Screw, Horn Button 1
25
639796
Horn Button Assembly 1
26
648304
Nut, Steering Wheel 1
27
518331
Steering Wheel 1
28
853408
Ball Nut 29
10J-09
Ball 30
853380
Gasket, End Cover 1
31
853376
Cover, Housing End 1
32
853373
Bearing, WormThrust 1
33
853385
Nut, Worm Bearing Adjuster Lock.
1
1
34
853372
Adjuster, Worm Bearing 1
No.
Req'd.
Steering Gear Assembly (Less 15,
16, 20, 25, 27 & 45 thru 49). . 1
1
1
8D-07
Nut, Lash Adjuster
2
1C-612
Bolt, Side Cover 3
3
2E-06
Lkwshr, Side Cover 3
4
853182
Cover Assembly, Housing Side —
Inc. Bushings 1
5
851756
Gasket, Side Cover 6
851770
Lash Adjuster
1
7
940111
Gear, Pitman Shaft
1
8
853357
Bushing, Pitman Shaft
2
9
5K-432
Extension, Filler
1
9A 22F-4 Cap, Filler
item
No.
Part
No.
24
106
10
940112
Housing Assembly (Inc. 8, 11 & 23) 1
35
3E-07
Lkwshr, End Cover 4
11
940113
Jacket, Column
1
36
1C-718
Bolt, End Cover — Short 3
12
857729
Bearing Assembly — Upper 1
37
1C-726
Bolt, End Cover — Long 1
13
853395
Spring, Upper Bearing
1
14
853394
Seat, Upper Bearing Spring
1
14A 853187 Lash Adjuster Shim Kit
37A 940119
tSpacer, End Cover 1
37B 940120
tNut, Block Lock 1
1
38
853412
Guide,BallReturn 4
39
853464
Clamp, Ball Return Guide 1
16A 622028 1Cover, Horn Cable Connector 1
40
851762
Bolt and Washer Assembly 3
2
41
853373
Bearing, Worm Thrust 16C 17E-10tLkwshr 2
42
940122
Shaft Assembly — Ball Nut, Contact
15 622027Screw, Horn Connector 2
16 622026Connector Assembly, Horn Cable 1
16B 622029 tScrew
and Steering (Inc. 21, 22, 28, 29,
16D 518346 tGasket, Connector Assy. 1
38 thru 41 & 43)
1
1
17
853391
Seal, Pitman Shaft Grease
18
3E-18
Lkwshr, Pitman Arm 1
19
850756
Nut, Pitman Arm 1
20
940114
Pitman Arm Assembly — 75A 1
43
940123
Shaft Ass'y., Worm & Steering (Inc.
21, 22 & 41) 1
44
853384
Key, Steering Wheel 1
45
550594
tU-Bolt, Steering Gear 1
46
550044
Klamp, Steering Gear 1
21 853368 Terminal Assembly, Horn 1
47
2C-832
1- Bolt 2
22 940115Contact Assembly, Horn Cable and 1
48
2D-08
tNut 4
23 853379Cup, Worm Thrust Bearing 1
49
4E-08
fLkwshr 4
20A 940125Pitman Arm Assembly — 75B 1
20B 940127 Pitman Arm Assembly -- 75R 1
tNot Illustrated
PM 1188
[65
)
▪
0
z
70
0
z
n
z
rn
t•I
0
z
a
CLINK
EQUIPMENT
MICHIGIM
STEERING BOOSTER ASSEMBLY
For Serial:
75A — 8123 Thru 8768
75B — 6123 Thru 6144
7123 Thru 7141
75R
Item
No.
Part
No.
Description
Steering Booster Assembly *For Replacement Use 513228
858302
Plug, Housing 858225
Spring, Housing Seat Pressure.
858226
Seat,Housing..... . .....
858227
Housing 1F-848
Cotter, Housing Plug 18D-06
Nut, Set Screw 10H-2
Fitting,HousingGrease 858264
Screw, Retainer Plate 858232
Plate, Retainer 858233
Spring, Shield 858234
Shield 858235
Cover 858236
Ball Stud 858237
Screw, Set 858238
Garter, Spring 858239
Wiper—Leather 858240
Spacer 858241
Wiper — Felt 858242
Retainer 858243
Adaptor — Upper 858244
Packing 858245
Adaptor — Lower 858246
Bushing, Cap 858247
Cap 25K-40216 "0" Ring 858249
Rod 1 F-424
Cotter, Rod Nut 858251
Ring 858252
Piston 858253
Nut, Rod 858254
Spring 25K-30018 "0" Ring 858256 Tube 858257
Cylinder 940146
Bolt 858259
Snap Ring 858260
Cap 940147
Sleeve 25K-40204 "0" Ring 858263
Cylinder Head Omit
Omit
10J-12
Ball No.
Req'd.
1
A *550596
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
1
2
4
4
1
2
2"
1
1
1
6
1
2
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
2
1
1
4
1
1
1
2
1
84
1
86
78
79
80
81
82
83
85
PM 11.88
ItemPart
No.No.
[ 67 ]
Description
No.
Req'd.
858266Guide 858267Spring 858268Guide 25K-30016 "0" Ring 858270Seat 858271Ball 858272Spring 940141
Screw, Flange — Long 858274
Washer, Flange Screw 862257
Flange — 1/2 P. Tap 25K-30020 "0" Ring 940145Nut 858278Washer 858279Spool 858280Spring 858281 Washer 858282Nut 858283Snap Ring 858284Guide 585285Spring 858286Oil Seal 858287Retainer 858288Sleeve 858289End Plate 858290Stem 858291Cover 17D-6Nut, Stay Bolt 858293Body 858294Plug 858295Key, Plug 858296Nut, Set Screw 17G-416 Screw, Set 858298Pad 858299Spring 10H-2Grease Fitting Omit
Omit
940148Spring 940149-Washer, Rubber 940128S6-I-1 Sub Assembly (Inc. 10 thru 12,
51, 52 & 69) 940079Repair Kit (Inc. 20, 21, 22, 25, 32,
47, 54 & 64) 6D-14tNut, Ball Stud 1F-428tCotter, Ball Stud Nut 1
1
1
2
1
1
1
4
4
1
2
2
1
1
1
1
1
1
1
4
1
1
1
1
1
1
1
1
1
1
1
2
2
CLgRK
MICHIG1111
EQUIPMENT
17
34
35
47
46
48
49
50
75
TS-176-P
PM 1188
68
CLIIRK
EQUIPMENT
MICHIGArl
For Serial:
75A — 8769 Thru 10082 & 10085 Thru 10089
75B — 6145 Thru 6195
75R — 7142 Thru 7150
ItemPart
No.No.
Description
A *552944 Steering Booster Assembly
*For Replacement Use 513228
1867580Snap Ring 2869021Key 3869020Plug 4869019Spacer 5869018Spring 6869017Seat, Ball Stud 7869016Seat, Ball Stud 8869015Key 9869014Nut 10869013 Washer 11869012Retainer 12869011Sleeve 1310H-2Grease Fitting 14868982Ball Stud 15858291Cover, Dust 16868981Spring 17868980Nut 18869010Retainer 1925K-40204 "0" Ring 20664131Pin,Roll 212D-07Nut 2225K-30020 "0" Ring 23868984Retainer, Spring 24940663Spring 25
Omit
26940664Spring 27868986Washer 2825K-20010 "0" Ring 29868988 Valve Spool 3012J-12Ball 31868992Spring 32868991Washer 33664138Snap Ring 3425K-40028 "0" Ring 35868993Snap Ring 36868994Plug 37940665Valve Body 3816F-04Plug — 1/4 " Pipe 3916F-02Plug — 1/8" Pipe 40940666Seat 41940667Poppet............. • • •
42940668*Shim 43940669Spring 4491F-5Seal 45940670Plug 46869006J-Stay Bolt Sub — Assembly 4725K-40216 "0" Ring No.
Req'd.
1
3
4
2
— As Required
PM 1188
(69 1
ItemPart
No.No.
Description No.
Req'd.
4825K-30016 "0" Ring 49869007Tube, Oil Passage 50869005Cylinder 5125K-30016 "0" Ring 52869008.Spring 534D-14Nut 541F-424Cotter 55868996Piston 56858251 Piston Ring 57868997Cap 58869000Nut 59664769Bushing — Oilite 60858245Male Packing 61858244Chevron; Packing 62858243Female/Packing 63 *858241 Felt Wiper 64 *868999 Packing Nut 65 * 869004Piston Rod 6618D-06Nut 67 *858237Screw 68868980Nut 69868981 Spring 70869001Shield 71858235Dust Cover 72858236Ball Stud 731F-848Cotter 74*858227Housing, Ball Joint 75858302Plug 76858225Spring 77858226Seat, Ball Stud 7810H-2Grease Fitting 7915G-612Set Screw 80940671*Repair Kit (Inc. 19, 22, 28, 34, 44,
47, 48, 51 & 60 thru 63) *Formachineserialnumbers listed
below items marked * are as indicated below:
75A
9148 thru 10082
75B
6160 thru 6195
75R
7142 thru 7150
63870732Felt Wiper 64870740Packing Nut 65870739Piston Rod 67870730Screw 74870736Housing, Ball Joint 1
1
1
1
1
1
1
1
1
1
4
1
1
5
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
CUIRK
1
2
MICHIG1111
EQUIPMENT
y
3
14
9
1013
12
17ID
19
20 21 22 23
4
2$ 26 2
28 a 30
31
32
39
41
42
11 1\1\
38 373635
66
61
68
63
64
65
70
71
72
TS-308
PM 1188
[ 70 ]
34
33
CUIRK
CONSTRUCTION
EQUIPMENT
MACHINERY DIVISION
MICHIGIM
75A — 10083, 10084, 10090 and Thereafter
75B — 6196 and Thereafter
75R — 71 51 and Thereafter
Item
No.
Part
No.
Description
Item
No.
No.
Req'd.
Part
No.
Description
No.
Req'd.
513228Steering Booster Assembly 1
40
940668Shim 1
867580Snap Ring 1
41
940669Spring 1
AR
2
869021Key 1
42
91F-5"0" Ring 1
3
869020Plug 1
43
861811Plug 1
4
869019Spacer
1
44
869006J-stay Bolt Sub-assy 4
5
869018Spring 1
45
25K-40216 "0" Ring 2
6
869017Ball Stud Seat
1
46
25K-30016 "0" Ring 1
869007Tube, Oil Passage 1
7
941818BallStudSeat 1
47
8
941816Lkwshr 1
48
869005Cylinder
941815Nut, Spool Adjusting 1
49
25K-30016 "0" Ring 1
941817Retainer 1
50
869008Spring 1
51
1D-14Nut 1
9
10
1
11
896011Sleeve 1
12
10H-2Grease Fitting 1
52
1 F-424Cotter Pin 1
13
868982Ball Stud 1
53
868996Piston
1
14
858291Dust Cover 1
54
858251PistonRing 15
868981Spring 1
55
868997Cap 1
869000Nut 4
1
16
868980Nut 1
56
17
869010Retainer 1
57
664769Oilite Bushing 1
58
858245Male Chevron Adaptor 1
18
25K-40204 "0" Ring 1
19
25K-30020 "0" Ring 1
59
858244Chevron Packing 5
858243Female Chevron Adaptor 1
20
868984Spring Retainer 1
60
21
940663Spring 1
61
870732Wiper Seal 1
62
870740Packing Nut 1
1
63
870739Piston Rod 1
1
64
18D-06Nut 1
1
65
870730Bolt 1
1
66
868980Nut 1
868981 Spring 1
22
23
24
25
26
Omit
940664Spring 868986Washer 25K-20010 "0" Ring 942779Valve Spool 27
10J-12Ball 1
67
28
868992Spring 1
68
869001 Shield 1
858235Dust Cover 1
29
868991Washer 1
69
30
664138Snap Ring 1
70
858236Ball Stud 1
1F-848Cotter Pin 1
31
25K-40028 "0" Ring 1
71
32
868993Snap Ring 1
72
870736Housing, Ball Joint 1
73
858302Plug
1
33
868994Plug 1
34
870744Valve Body (Inc. 37) 1
74
858225Spring 1
3
75
858226Ball Stud Seat 2
76
10H-2Grease Fitting 77
942672"0"RingRepair Kit (Inc. 18, 19,
AR
25, 31, 39, 42, 45, 46, 49) 78
942668Chevron Packing Repair Kit (Inc.
58, 59, 60, 61) 35
16F-04Plug — 1/4" Pipe 36
16F-02Plug — 1/8" Pipe 1
37
940666Seat
1
38
940667Poppet 1
39
942806Back Up Washer 2
AR — As Required
PM 1188
[
71
AR
CLARK
EQUIPMENT
STEERING BOOSTER
PUSH ROD ASSEMBLY
Item
No.
Part
No.
1
2C-832
Bolt, Push Rod to Booster 4
2
4E-08
Lkwshr, Push Rod to Booster Description
No.
Req'd.
No.
Req'd.
Fitting, Tie Rod End Grease 2
4
10
616813
Washer 2
11
1F-426
Cotter 2
12
550600
Nut, Push Rod to Booster 4
4
550597
Push Rod Ass'y., Booster to Crank.
1
5
550602
Pin
6
10H-25
Grease Fitting 2
7
106110
Tie Rod End Ass'y. — See Index.
8
550604
Rod Description
11H-15
2D-08
PM 1188
AXLE
9
3
ItemPart
No.No.
MICHIGAII
Bell Crank Assembly (Inc. 12A & 13)
1
12A 550187
Bell Crank 1
13
550601
Bushing 2
14
1F-424
Cotter 2
2
15
617863
Nut 2
1
16
2
[ 72
Steering Booster — See Index
MARK
EQUIPMENT
MICHIGIIII
TIE ROD END ASSEMBLY
MODEL 75A AND 75B
Item
No.
Part
No.
A
106110
Description
MODEL 75R
No.
Req'd..
Tie Rod End Ass'y. (Inc. 1 thru 15)
MODEL 75A MODEL 75B 2
106094
Snap Ring 1
2
106091
Spring 1
3
106093
Cap 1
4
2C-1040
Bolt 2
5
4E-10
Lkwshr 2
6
2D-10
Nut 2
7
106113
Housing 1
8
106080
Ball Stud 1
9
4D-12
Nut, Ball Stud 1
10
106182
Spring,Retainer 1
11
106138
Retainer, Felt 1
12
106137
Felt 1
13
106114
Socket, Ball Stud 2
14
106079
Retainer, Ball Stud Socket 2
15
106088
Washer .
Part
No.
B
106145
C
106146
1
2
3
4
5
6
7
7A
8
9
10
11
12
13
14
15
940152
940153
940154
1C-832
4E-08
1D-08
106147
106148
940155
100857
102438
102435
102436
940156
940157
940158
4
1
PM 1188
Item
No.
[73
1
Description
No.
Req'd.
Tie Rod End Ass'y. — R.H. (Inc. 1
thru 7 & 8 thru 15) Tie Rod End Ass'y. — L.H. (Inc. 1
thru 6 & 7A thru 15) Snap Ring Spring Cap Bolt Lkwshr Nut Housing Housing Ball Stud Nut, Ball Stud Spring,Retainer Retainer, Felt Felt Socket,BallStud Retainer,BallStud Socket Washer 3
1
1
1
2
2
2
1
1
1
1
1
1
1
2
2
1
MARK
EQUIPMENT
MICHIGAll
DRAG LINK ASSEMBLY
Item
Part
No.
No.
Drag Link Assembly (Inc. 1 thru 5) MODEL 75A
MODEL 75B
MODEL 75R
1
940011
940015
940016
Plug, Ball Seat Adjustment Ball Seat Spring 1
1
1
Drag Link Forging MODEL 75A
MODEL 75B
MODEL 75R
1
940017
940131
940132
940018
10H-2
1F-432
Plug, Safety Fitting, Drag Link Grease Cotter 4
5
6
7
PM 1188
Req'd.
550595
550781
550788
A
1
2
3
No.
bescription
[ 74 ]
1
1
CLARK
miCHIGAn
EQUIPMENT
2
0
1; 1
a
18
17
0
Ii• MO ■
al Elf
16
1514
121110
13
T5-171 - PI
HYDRAULIC SYSTEM STEERING
MODEL 75A
For Serial 8123 Thru 10222, 10240 and 10247 Thru 10251
Item
No.
Part
No.
1
550700
Adaptor Union — Special — 90° 1
2
550612
Coupling 1
3
550610
Tee
1
4
550611
Tube, Steering Booster 2
5
550614
Lug, Steering Booster Tube 2
6
550608
Description No.
Req'd.
Item
No.
Part
No.
11661564
11A 91F-6
12
Hydraulic Line Assembly (Inc. 2 thru
5 & 9) 2
1'0" Ring — For Serial 8769 thru
10222,10240 &10247 thru
10251 2
Hydraulic Oil Reservoir—See Index
15661560
Hose, Return Line to Reservoir..
1
16661559
Hose, Pump to Hydraulic Line 2
Adaptor Union — 1/2" — 90°
Booster Pump — See Index
1
2
8
4E-06
Lkwshr, Lug Attaching 2
9
550612
Coupling 2
1731 F-4
10
661559
Hose, Line Ass'y. to Steering Booster
2
18
75 ]
10240 & 10247 thru 10251....
Bolt, Lug Attaching Union Adaptor, "0" Ring Seal -For Serial 8769 thru 1 0 2 2 2,
1431 F-4
552152
PM 1188
No.
Req'd.
13
7
Description
1
CUIRK
EQUIPMENT
MICHIGAI1
MODEL 75A
Effective With Serial 10223 Thru 10239,
10241 Thru 10246, 10252 And Thereafter
ItemPart
No.No.
Description
No.
Req'd.
Item
No.
Part
No.
Description
No.
Req'd.
2
131F-4
1
8
661559
Hose, Pipe Assembly to Booster... 2712766
Hose, Pipe Assembly to Reservoir.
1
9
661564
Union Adaptor, "0" Ring Seal... . 2
3666846
Nipple, Reservoir to Pump Hose..
1
10
91F-6
"0" Ring
421H-24
Clamp, Reservoir to Pump Hose. ..
1
5516159
Hose, Reservoir to Pump 1
621H-24
Clamp, Reservoir to Pump Hose...
1
7514610
Pipe Assembly 1
14
tBolt, Pipe Assembly to Frame 2
7B 2D-06
tNut, Pipe Assembly to Frame 2
15
7C 4E-06
itkvishr, Pipe Assembly to Frame..
2
16
666858
[ 76 ]
Nipple, Reservoir to Pump Hose. .. 1
Hydraulic Steering Pump—See Index
13
7A 2C-624
PM 1188
Steering Booster Assembly—See Index
11
12
2
514788
Adaptor Union
661563
Hose, Pump to Pipe Assembly CLARK
MICHIGI111
EQUIPMENT
A001111111111111 111111: 11111 1111 111 1111 1 -M1111■
13
11
10
T5-172-PI
MODEL 75B
For Serial — 6123 Thru 6200
Item
No.
Part
No.
1
550700
Adaptor Union, Pump Suction Line 1
10
2
661560
Hose, Pump Suction Line 1
11
31F-4
Adaptor Union — 1/2" — 90° .2
3
552152
Bolt, Hydraulic Line Mtg. 2
12
6615 59
Hose 4
4E-06
Lkwshr, Hydraulic Line Mtg. 2
13
5
550809
Hydraulic Line Assembly 1
6
661559
Hose, Booster to Hydraulic Line 2
7
661564
Union Adaptor, "0" Ring Seal—
Description
No.
Req'd.
for Serial 6145 thru 6200 91F-6
2
"0" Ring — For Serial 6145 thru
6200 2
PM 1188
[ 77 ]
ItemPart
No.No.
.
Description
No.
Req'd.
Hyd. Pump — Steering Booster —
See Index
14
550782
1- Adaptor, Steering Booster
15
2C-828
tBolt, Booster to Adaptor 4
16
2D-08
-I- Nut,
17
4EA)8
tLkwshr, Booster to Adaptor 4
18
1F-424
tCotter
1
19
10H-25
t Grease Fitting
1
1
Booster to Adaptor 4
CLARK
EQUIPMENT
14
mICHicpn
13
MODEL 75B
ItemPart
No.No.
Description
Item
No.
No.
Req'd.
1
2517119
Steering Pipe Coupling Assy. 2A 2C-624
tBolt, Booster Pipe to Frame 2B 2D-06
- Nut, Booster Pipe to Frame 2C 4E-06
tLkwshr, Booster Pipe to Frame 11
3661559
Hose, Booster Lines 4672806
Hose, Return Line 1
1
1
1
2
1
531F-4
Adaptor Union, Tank to Return Hose
— 1/2" x 90° 1
6666846
Nipple, Uncoupled Hose — Tank to
Pump 721H-24
Clamp, Pump Suction Line Hose 8516159
Hose, Pump Suction Line 921H-24
Nipple, Uncoupled Hose — Suction
Hose to Pump Description
No.
Req'd.
Hyd. Pump — Steering Booster —
See Index
12
514788
Adaptor Union, Pump to Pressure
Hose
13
1
1
1
1
PM 1188
Part
No.
78 I
14
661563
Hose, Pump Pressure Line
1
15
661564
Union Adaptor, "0" Ring Seal. 2
16
91F-6
"0" Ring 17
550782
tAdaptor, Steering Booster
18
2C-828
tBolt, Booster to Adaptor 4
19
2D-08
1- Nut, Booster to Adaptor 4
20
4E-08
21
1F-424
-I-Cotter
22
10H-25
tGrease Fitting 2
1
1
CUIRK
mIcHicnn
EQUIPMENT
MODEL 75R
For Serial — 7123 Thru 7154
Item
No.
Part
No.
Description No.
Req'd.
ItemPart
No.No.
1
550700
Adaptor Union, Pump Suction Line 14
2
661562
3
661568
5
Control Valve Assembly—See Index
6
31F-4
Adaptor Union, Valve to Pump Suction Line Description
No.
Req'd.
Steering Booster—See Index
552152
Bolt, Hydraulic Line Assy. Mtg.. 2
2
16
4E-06
Lkwshr, Hydraulic Line Assy. Mtg.. 17
550814
Hydraulic Line Assy.
1
18
661561
Hose, Pump Pressure Line
1
19
31F-4
Adaptor Union, Pump to Pressure
1
Hose 7
552149
Clip,Booster Lines 8
2C-516
Bolt, Clip 20
9
2D-05
Nut, Clip 21
550789
tAdaptor, Steering Booster. .. .1
10
4E-05
Lkwshr, Clip 22
2C-828
tBolt, Steering Booster to Adaptor 4
11
661563
Hose, Booster Lines 2
23
2D-08
t Nut, Steering Booster to Adaptor 4
12
661564
Union Adaptor, "0" Ring Seal (For
Serial 7142 & thereafter) 2
24
4E-08
t Lkwshr, Steering Booster to Adaptor 4
25
1F-424
tCotter
1
26
10H-25
tGrease Fitting
1
13
91F-6
"0" Ring (For Serial 7142 & thereafter) 2
2
PM 1188
[ 79 ]
Hyd. Pump—Steering —See Index
CLARK
MICHIGlin
MACHINERY DIVISION
CONSTRUCTION
EQUIPMENT
HYDRAULIC SYSTEM — STEERING
MODEL 75R
Effective with Serial— 7155 and Thereafter
Item
No.
No.
Req'd.
Part
No.
No.
Req'd.
Item
No.
Part
No.
1
661563
Hose, pump Pressure Line 1
13
2C-624
Bolt, Booster Pipe to Frame
2
31F-4
Adaptor Union, Reservoir 1
14
4E-06
Lkwshr, Booster Pipe to Frame 2
15
2D-06
Nut, Booster Pipe to Frame 2
Description Hydraulic Oil Reservoir —See Index
3
Description
2
4
666846
Uncoupled Hose Nipple, Reservoir .
1
16
517157
Pipe Assembly, Steering Booster. 1
5
21H-24
17
514788
Adaptor Union, Pump 6
516159
18
672712
Hose, Return Line
7
666858
Uncoupled Hose Nipple, Pump 1
19
550789
tAdaptor, Steering Booster
1
20
2C-828
-
I- Bolt, Booster to Adaptor
4
Steering Booster Pump — See Index
8
1
1
I- Nut, Booster to Adaptor 4
9
661563
Hose,Booster Line 2
21
2D-08
-
10
661564
Union Adaptor, "0" Ring Seal.
2
22
4E-08
11
91F-6
"0" Ring
2
23
1F-424
tCotter
1
24
10H-25
tOrease Fitting
1
12
PM 1188
1 80 ]
CUIRK
EQUIPMENT
MOWN
HYDRAULIC PUMP STEERING
For Serial:
75A8123 Thru 10222, 10240 and 10247 Thru 10251
75B 6123 Thru 6200
75R7123 Thru 7154
Item
No.
Port
No.
Description Item
No.
No.
Req'd.
No.
Part
No.
Description
Req'd.
A
*550243
Hydraulic Gear Pump (Inc. 1 thru 19)
11
940049
Gear, Drive 1
B
*941640
Minor Repair Kit (Inc. 4, 7, 10, 16)
12
940059
Gear, Driven 1
C
*941652
Major Repair Kit (Inc. 1, 2, 4, 7, 8,
9, 10, 13, 14, 16)
13
940048
Bearing, Body Drive 1
D
*942428
Drive & Driven Gear Set (Inc. 11 &
12)
14
940060
Bearing, Body Driven 1
Body 1
Shaft Seal 1
15 *942364
1
940056
Bolt, %" — 16 x 11/4" hex head. .
5
16
940045
2
713134
Washer 5
17
941770
t Retainer, Shaft Seal 1
3 *940052
Cover
1
18
941771
1- Screw, Retainer 2
4
Seal Ring, Seal Relief 19
NPN
fLockwire,Retainer Screw.... . . .
1
20
551479
tGasket, Pump Mounting 1
21
6J-404
tKey, Gear Drive — No. 4 Woodruff
1
940057
5 °
Omit 6 °
Omit 1
7
940051
Seal Ring, Bearing 2
8
940050
Spring, Bearing 1
22
551480
-
I-Washer, Gear 1
9
940058
Bearing, Cover Drive & Driven ....
2
23
4D-06
-
Nut, Gear 1
10
940047
Seal Ring, Cover 1
24
1F-316
-
I- Cotter,Nut * — Only these items available as replacement parts.
° — Spring & Ball to be omitted from all pumps when
rebuilt.
NPN — No Part Number
PM 1188
[ 81 j
CUIRK
MICHIG1111
EQUIPMENT
HYDRAULIC PUMP CONVERTER CHARGING AND STEERING BOOSTER
75A10223 Thru 10239, 10241 Thru 10246, 10252 and Thereafter
75B6201 and Thereafter
75R — 7155 and Thereafter
Item
No.
Part
No.
Description No.
Req'd.
Item
No.
Part
No.
Description No.
Req'd.
A
*941653
10
942514
Spring, Bearing 1
B
*942403
Minor Repair Kit (Inc. 5 thru 9)
11
942515
Bearing, Cover Drive 1
C
*942404
Major Repair Kit (Inc. 1, 2, 3, 5 thru
12, 15, 17, 18)
12
942516
Bearing, Cover Driven 1
D
*942432
14)
13
942517
Gear, Drive 1
14
942518
Gear, Driven 1
15
942519
Bearing, Body Drive & Driven 2
16
942652
Plug, Seal Relief 1
17
942520
Spring, Seal Relief 1
18
10J-10
Ball, Seal Relief — 5/16" 1
19 *942670
Body 1
20
16F-02
Plug, Seal Chamber 1
1
2D-06
Nut, 3/8" — 24 hex 2
713134
Washer 3
2C-656
Bolt, 3/8" -- 24 x 3 1/2" hex head 4
*942513
Cover
5
713133
Ring, Seal Retainer 6
942648
Shaft Seal 7
942649
SealRing,Cover 8
942650
Back Up Washer 2
21
551906
tGasket, Pump Mounting 9
942651
Seal Ring, Cover Bearing 2
22
514788
tAdaptor Union
8
16
8
* — Only these items available as replacement parts
PM 1188
[82
1
1
1
CUIRK
EQUIPMENT
MICHIGI111
HYDRAULIC OIL RESERVOIR AND PARTS
ItemPart
No.No.
Description
Item
No.
No.
Req'd.
No.
Req'd.
1 A 553284Oil Reservoir Effective with Serial:
75A — 9280 and thereafter
75B — 6163 and thereafter
1
2550388Cap, Breather 32C-820Bolt, Reservoir Mtg. 44E-08Lkwshr, Reservoir Mtg. 52D-08Nut, Reservoir Mtg. 1
3
3
3
7
550389
Cover, Inspection 8
550398
Clamp Ring, Inspection Cover 9
618319
Copper Washer, Inspection Cover .
6
For Serial:
75A — 8123 thru 9279
75B — 6123 thru 6162
75R — 7123 thru 7141
4E-06
Lkwshr, Inspection Cover 6
ForSerial:
6550397Gasket, Inspection Cover ForSerial:
75A — 8123 thru 9279
75B — 6123 thru 6162
75R — 7123 thru 7141
6A 25K-40428 "0' Ring, Inspection Cover Effective with Serial:
Description 75B — 6163 and thereafter
1940396Oil Reservoir Kit (Inc. 1A, 6A, 7, 8,
9A, 10 & 11) For Serial:
75A — 8123 thru 9279
75B — 6123 thru 6162
75R7123 thru 7141
PM 1188
Part
No.
10
2C-616
Bolt, Inspection Cover 6
11
11F-12
Pipe Plug — For Serial 1
75A — 9280 thru 10222,10240
and 10247 thru 10251
75B — 6163 thru 6200
75R — 7142 thru 7154
[ 83 ]
CLARK
EQUIPMENT
DIVISION
MICHIGAll
HYDRAULIC PUMP - BUCKET AND BOOM
For Serial:
75A — 8123 Thru 9745
75B — 6123 Thru 6184
75R7123 Thru 7150
Item
No.
Part
No.
Description Item
No.
Req'd.
No.
Part
No.
Description No.
Req'd.
A °*550242
9
940586
B*941643
Minor Repair Kit (Inc. 4, 6, 7, 16, 18)
10
940587
C0 941645
Major Repair Kit (Inc. 1, 2, 3, 4, 6
thru 10, 13, 14, 16 thru 20)
11
940003
Gear, Drive 1
12
940013
Gear, Driven 1
D°942427
12)
13
940584
Bearing, Body Drive 1
14
940585
15 °942356
Body 1
16
940014
Seal Ring, Cover 1
17
853753
Retainer, Seal Relief 1
1940006
Nut, 7/16" — 14 Hex 8
2940008
Washer 8
3940000
Bolt, 7/16"-14 x 4 1/2" Hex Head 8
4940005
Shaft Seal 1
5 *940009
Cover
1
18
853749
Gasket, Seal Relief 1
6941566
Back up washer 2
19
853751
7940010
SealRing
2
20
10J-10
Ball, Seal Relief — 5/16" 1
8853433
Spring
6
21
853754
Seat,Ball 1
* — Use 553417 For Complete Pump Replacement
° — Only these items available as replacement parts
PM 1188
[84
1
CUIRK
EQUIPMENT
MICHIG1111
HYDRAULIC PUMP BUCKET AND BOOM
Effective
75A -- 9746
75B — 6185
75R7151
Item
No.
Part
No.
Description with Serial
and Thereafter
and Thereafter
and Thereafter
No.
Req'd.
ItemPart
No.No.
Description
No.
Req'd.
A
*553417
9
940010
Seal Ring, Bearing 2
B
*941644
Minor Repair Kit (Inc. 5 thru 9, 18)
10
853433
Spring, Cover Bearing 6
C
*941646
Major Repair Kit (Inc. 1, 2, 3, 5 thru
11
941563
12
941562
13
941560
Gear, Drive 1
14
941557
Gear, Driven 1
15
941561
Bearing, Body Drive
1
16
941561
12, 15, 16, 18, 19, 20)
D
*942431
14)
940006
Nut, 7/16" — 14 Hex 8
2
942357
Washer 8
3
940000
Bolt, 7/16" — 14 x 4 1/2" Hex Head
8
4
*941556
Cover
1
17
941558
Retainer, Seal Relief
1
5
666542
Ring, Seal Retainer 1
18
941555
Gasket, Seal Relief 1
6
941564
Shaft Seal 1
19
941565
7
940014
Seal Ring, Cover 1
20
941552
Ball, Seal Relief1/2 '' 1
8
941566
Back Up Washer 2
21
*941559
Body 1
* — Only these items available as replacement parts.
PM 1188
[ 85 ]
CLeiRK
EQUIPMENT
MICHIGAN
HYDRAULIC SYSTEM BUCKET AND BOOM
For Serial:
75A — 8123 Thru 9745
75B — 6123 Thru 6184
75R — 7123 Thru 7150
Item
No.
1
2
3
4
5
6
7
8
9
Part
No.
33F-5
512108
36F-5
31F-5
550723
616533
10
11
12
13
14
15
16
17
645432
691800
550728
550724
Description No.
Req'd.
Control Valve — See Index 2
Adaptor Union — 3/4" 45 0 Bushing, Pipe Reducing- 34" to 1" 3
10
Adaptor Union — Straight — 3/4
4
/4"
90
0
Adaptor Union — 3
Hydraulic Oil Reservoir — See Index
2
Hose — 36" 3
Hose — 27" Boom Pipe Assembly — L. H. -See Index Boom Pipe Assembly — R. H. —
See Index Hose — 22" 3
4
Hose — 24" Bucket Cylinder — See Index Crosspipe Assembly, Control Valve
1
to Boom Cyl. Rod End Hose — 34" Boom Cylinder— See Index Main Hydraulic Pump — See Index
Part
No.
18
550725
19
20
21
2C-620
2D-06
4E-06
-
" .
Description
No.
Req'd.
Crosspipe Assembly, Control Valve
1
to Boom Cyl. Head End t Bolt, Crosspipe Mounting 4
t Nut, Crosspipe Mounting 4
tLkwshr, Crosspipe Mounting 4
For Serial #8123 thru #9279
22
25F-7
23
24
25
610386
550718
31F-7
Adaptor Union — 1 1/4" - 45 0 .1
1
Hose — 18" Hose, Sump to Pump — 17 1/2 ".1
Adaptor Union — 1 1/4" - 90 0 ...1
For Machine Serial #9280 thru
#9745
22
23
24
24A
25
PM 1188
Item
No.
[ 86 ]
553339
610386
553340
941449
Nipple, Special
Hose — 18" Hose, Suction
Clamp, Suction Hose Omit
1
1
1
2
CLeiRK.
MICHIG1111
EQUIPMENT
101 1
14
13
15
16
12
2524 23 22 21
26
I
20
imi
191817
21
/
28
30
31 32
33
W O E.' 41 40-39 38
TS-204 P-1
31
36
dfl
29
3534
HYDRAULIC SYSTEM BUCKET AND BOOM
75A — 9746 and Thereafter
75R — 7151 and Thereafter
Item
No.
Part
No.
1
2
3
4
' 5
6
7
8
9
10
10A
11
11A
12
13
14
512108
36F-5
Description
No.
Req'd.
Bushing, Pipe Reducing Adaptor Union, Valve to Pump Hydraulic Oil Reservoir—See Index
553419
Hose, Pump to Valve 941449
Clamp, Reservoir to Pump Hose Hose, Reservoir to Pump... 553340
941449
Clamp, Reservoir to Pump Hose 553339
Nipple Assembly, Pump Main Hydraulic Pump—See Index
663093
SplitFlangeHalf 25K-40110 1- "0" Ring Bolt, Flange to Pump .....
1C-620
4E-06
tLkwshr, Flange to Pump 36F-5
Adaptor Union — Straight -- 3/4"
550723
Hose, Crosspipe to L.H. Boom Pipe
Boom Pipe Assembly, L.H. — See
Index 15
31F-5
Adaptor Union, Boom Pipe to Cyl 16
691800
Hose,L.H.BoomPipe toBucket
Cyl. 17
Bucket Cylinder Assembly — See
Index
18
645432
Hose, R.H. Boom Pipe to Bucket Cyl.
19
36F-5
Adaptor Union, Boom Pipe to Cyl.
20
550728
Crosspipe Assembly, Cyl. Rod End
20A 2C-620
tBolt, Crosspipe to Frame 20B 2D-06
tNut, Crosspipe to Frame 20C 4E-06
tikwshr, Crosspipe to Frame 21
36F-5
Adaptor Union, Crosspipe to Cyl 22
616533
Hose, Crosspipe to Boom Cyl.... ItemPart
No.No.
1
1
23
1
1
1
1
691800
550725
2C-620
2D-06
4E-06
616533
610386
28
29
30
31
32
33
34
645432
36F-5
691800
616533
36F-5
31F-5
691800
2
1
4
4
2
1
2
2
1
2
2
2
1
1
(87 1
No.
Req'd.
Boom Cylinder Assembly — See
Index Hose, Crosspipe to Boom Cyl Crosspipe Assembly, Cyl Head End
tBolt, Crosspipe to Frame tNut, Crosspipe to Frame itkwshr, Crosspipe to Frame Hose, Valve to L.H. Boom Pipe Hose, Valve to Cyl. Head End
Crosspipe Hose, Valve to R.H. Boom Pipe Adaptor Union — Straight — 3/4"
Hose, Crosspipe to Boom Cyl. Hose, Crosspipe to Boom Cyl. Adaptor Union, Crosspipe to Cyl.
Adaptor Union, Boom Pipe to Cyl.
Hose,L.H.BoomPipe to Bucket
Cyl. 1
1
2
2
2
1
1
1
2
1
1
1
1
1
Boom Pipe Assembly — R.H.
See Index 35
— Not Illustrated
PM 1188
24
25
25A
25B
25C
26
27
Description 36
37
550723
550724
Hose, Crosspipe to R.H. Boom Pipe
Hose, Valve to Cyl. Rod End
Crosspipe 1
38
39
40
33F-5
512108
36F-5
Adaptor Union — 3/4 " 45 0 . Bushing,PipeReducing Adaptor Union, Valve to
Crosspipe 2
1
41
31F-5
Adaptor Union, Valve to Boom
Pipe -
1
1
0
•
0
0of riPV . ir=-Ard, AMMI415
/
qgwasAdvau..
terAgaror _es Am
11
ititag,"-si
41a-lo
pp
wf
1 ,,k vrwAisriWimerAll•
7orNME r 11/
Pr/A
ith
00
11111 I
LO
T Mumma W
AIMIIIIIIT
AY.>
i i mvjj pi
III VAINIAMIVANN%
0
ell
der41
gtv.ilMO
firn
/ -71
''
44•1111111111
• mwv
„ ,,,
---\--....
\ 111111110SW,......
-11-:•
mfrt-.
0
lifelbAkli\10 allogiziapimi
•miniiiiii.
1W
...
a
de.
'11 ILI!ID
i \7141W41WA410
J.
10,i1111 1101M1 f011111
7 Nal*
ffaIlLi m ■limmirrailv..(■■
ar Mr
Orpr
";
Ikirvi AIWA
1 (0
r
Vic
CONTROL VALVE
CUIRK
CONSTRUCTION MACHINERY DIVISI 0 N
EQUIPMENT
mICHIGAn
CONTROL VALVE ASSEMBLY
Item
Part
No.
No.
A
550282
Description No.
Item
Part
Req'd.
No.
No.
Control Valve Assembly —
Complete
1
1
No.
Description Req'd.
20
940031
Gasket
1
21
940025
Cap, Adjustment 1
22
8D-06
Nut, Jam
1
23
863045
Nut, Acorn
24
940028
Screw, Adjustment 25
940029
Guide, Spring 1
940040
Cap, Detent
2
940023
Cap, Detent Valve
3
940024
Spring,Detent 4
940041
Gasket
5
940061
SealRing 26
940030
Spring 6
940062
Spacer, Plunger 27
940032
Plunger,Relief Valve 7
940063
Spring 28
940033
Seat, Relief Valve 1
8
940064
Plunger, Check Valve 3
29
863052
Screw
1
9
25K-40116
Seal Ring
1
30
863053
Gasket
16F-16
Pipe Plug 1
31
863051
Screw, Set 1
32
10
11
12
§Operating Plunger (See A) 16F-08
13
14
2
PipePlug § Housing (See A) 862092
15
Seal
2
§Operating Plunger Ass'y. — Float
16
940068
Plunger Eye 17
940022
Seal Assembly 18
§Operating Plunger Ass'y. — D.A.
(See A) 19
1
940070
1
Spring § — Not Sold Separately
PM 1188
89
1
§Operating Plunger (See A) 33
940072
Spring 1
34
16F-12
PipePlug 35
940073
Cap
36
940039
Cap
37
940074
Washer 38
940075
Poppet, Detent Plunger 39
16F-06
tPipePlug 40
2C-856
tBolt, Valve to Reservoir 3
41
4E-08
fl_1;vshr, Valve to Reservoir 3
1
CUIRK
E QUIPMENT
MICHIGAll
VALVE CONTROL LEVERS AND LINKAGE
Item
Part
No.
No.
1
Description No.
Item
Part
Req'd.
No.
No.
Description
14
300208
Knob, Boom Valve Lever 1
Control Valve Assembly—See Index
No.
Req'd.
2
4F-08127
Pin, Valve Rod to Valve Clevis.
1
15
550640
Valve Lever Ass'y., Boom 1
3
550647
Valve Rod -Assembly 1
16
554081
Bushing,Lever Mtg. 1
4
8D-08
Nut, Yoke Jam 1
17
550646
Sleeve, Lever Mtg. 1
5
4J-8300
Yoke, Valve Rod 1
18
616796
Washer, Lever Mtg. 1
6
4F-08127
Pin, Yoke Clevis 1
19
4E-08
Lkwshr, Lever Mtg. 1
7
2C-868
Bolt,Lever Mtg. 1
20
2D-08
Nut, Lever Mtg. 1
8
616796
Washer, Lever Mtg
1
21
4F-08127
Pin, Yoke Clevis 1
9
550646
Sleeve, Lever Mtg. 1
22
4J-8300
Yoke, Valve Rod 1
10
554081
Bushing, Lever Mtg. 1
23
8D-08
Nut, Yoke Jam 1
11
300208
Knob, Bucket Valve Lever 1
24
550647
Valve Rod Assembly 1
12
550644
Valve Lever Ass'y., Bucket 1
25
4F-08127
Pin, Valve Rod to Valve Clevis.
1
13
1F: 414
Cotter,ClevisPin 1
26
1F-414
Cotter,ClevisPin 2
PM 1188
.
[ 90 ]
CUIRK
EQUIPMENT
1011 12 13 1
456
4
15
16
•
MOODilit
rikk2ezzacc-i
I 9roal
■
-- 7- -
FEan
k, / A
Z#
T S - 12-13
23 22 21201918
11
BOOM CYLINDER ASSEMBLY
Item
No.
Part
No.
A
551991
Description
No.
Req'd.
Boom Cylinder Ass'y. (Inc. 1 thru
23) 1
4C-616
Bolt,Retainer 1 A 550099
Lockwire, Retainer Bolt 2 550089
Retainer, Piston Rod Wiper
3
25K-40416 "0" Ring, Cylinder Cap 4 4E-08
Lkwshr, Cylinder Cap 5 2D-08
Nut, Cylinder Cap 6 2C-852
Bolt, Cylinder Cap 7 550083
Piston Rod Ass'y. (Inc. 23) 8
551992
Boom Cylinder 9 25K-40112 "0" Ring, Piston Rod 10 514741
"T" Ring, Chevron Packing
Adaptor 11
514742
Packing, Chevron 12 514740
"V' Ring, Chevron Packing
Adaptor 12A 514743
tShim 13 550081
Ring, Piston Wear 14 550080
Piston 15 551605
Nut,PistonRod 161F-648
2
8
2
2
2
8
8
8
2
2
2
2
8
2
2
4
2
2
— As Required
PM 1188
ItemPart
No.No.
] 91 ]
17552487
18552483
1 9552486
.
19A 552982
20550085
21550087
22550088
23550066
24942408
25942409
26942406
27942407
282C-872
292D-08
304E-08
Description
No.
Req'd.
Cotter, Piston Rod Nut "V" Ring, Chevron Packing
Adaptor 2
2
Packing, Chevron "T" Ring, Chevron Packing
Adaptor tShim 8
Cap, Cylinder Packing Gland Wiper, Piston Rod Bushing, PistonRod Chevron Packing & Adaptor Kit
(Inc.10 Thru 12A) ChevronPackingKit(Inc.11 &
12A) tChevron Packing & Adaptor Kit
(Inc. 17 Thru 19A) #ChevronPacking Kit(Inc.18 &
19A) tBolt, Pivot Shaft to Cyl. tNut, Pivot Shaft to Cyl. tLkwshr, Pivot Shaft to Cyl. 2
2
2
2
2
2
2
2
2
CUIRK
MICHIG1111
EQUIPMENT
101112 13 14 15 1617
5
r//
Jr Ar z . wie A 4 /M."
\
Ki ZSC
IO
P
0
F-11,
VA
23
.1ffeCaus.
gell
7111
.. 11 7
\
toll
22 21*
--W1
18
TS - 13 - P3
20 19
q9,4 g54Akkakoktik
ugit)
BUCKET CYLINDER AS EMBLY
ItemPart
No.No.
Description
No.
Req'd.
Bucket Cylinder Ass'y. (Inc.1thru
24) Wiper, Piston Rod 1550088
Retainer, Piston Rod Wiper 2550089
Packing Gland 3550087
425K-40416 "0" Ring, Cylinder Cap "T" Ring, Chevron Packing Adaptor
5552486
6552483
Packing, Chevron "V" Ring, Chevron Packing Adaptor
7552487
7A 552982
tShim 8550097
Piston Rod Assy. (Inc. 18 & 25). .
9514167
Cylinder & Bushing Ass'y. (Inc. 18
& 25) 1025K-40112 "0" Ring, Piston Rod 11514741
"T" Ring, Chevron Packing Adaptor
12514742
Packing, Chevron 13514740
"V" Ring, Chevron Packing Adaptor
13A 514743
tShim 14550081
Ring,Piston Wear ItemPart
No.No.
A514166
2
2
2
2
2
2
8
2
2
2
15550080
Piston
2
Nut, Piston Rod 2
171F-648
Cotter, Piston Rod Nut 2
18550229
Bushing 4
192D-08
Nut, Cylinder Cap 8
204E-08
Lkwshr, Cylinder Cap 8
21550085
Cap, Cylinder 2
222C-852
Bolt, Cylinder Cap 8
234C-616
Bolt,Retainer 8
2410H-25
2
2
2
8
2
2
4
[ 92 ]
No.
Req'd.
16551605
23A 550099
— As Required
— Not Illustrated
PM 1188
Description
Lockwire, Retainer Bolt -
I- Fitting,Grease 25942408
tChevron Packing & Adaptor Kit
(Inc. 11thru 13A) 26942409
$ChevronPacking Kit (Inc.12&
13A) 27942406
tChevron Packing & Adaptor Kit
(Inc. 5 thru 7A) 28942407
tChevron Packing Kit (Inc. 6 & 7A)
2
4
CLeIRK
EQUIPMENT
MICHIGAll
BRAKE ASSEMBLY FRONT
Item
No.
Part
No.
A
106335
106336
2
3
4
5
1H-410
106180
106526
106179
106337
6
106338
7
107611
7A 107612
7B 106184
8
107014
8A 940130
9957212
Description No.
Req'd.
Brake Assembly — R.H. (Inc. 1 thru
1
5 & 7 thru 27) Brake Assembly — L.H. (Inc. 1 thru
1
4 & 6 thru 27) 4
Rivet Link Support 1
Link Support 1
Link Assembly 1
Link Support Brake Disc Assembly — R.H. (Inc.
1
1, 2, 4, 15 & 23 thru 25) Brake' Disc Assembly — L.H. (Inc.
1
1, 2, 4, 15 & 23 thru 25) Brake Shoe Assembly (Inc. 7A, 7B &
2
20) 2
Lining, Brake Rivet, Brake Lining 36
1
Brake Cylinder (Inc. 9) Repair Kit, Brake Cylinder Connector Link, Brake Cylinder 2
,
Part
No.
10
11
12
13
14
15
16
17
18
106216
106969
101332
100878
102322
100864
106185
104524
106373
19
20
21
22
106970
100872
2D-12
4E-12
100865
100867
106372
4E-06
1C-610
23
24
25
26
27
— As Required
PM 1188
Item
No.
93
Description No.
Req'd.
Spring, Release Pin, Anchor "C" Washer, Anchor Pin . "C" Washer, Guide Pin .
Washer, Guide Pin Cam, Shoe Adjusting Spring, Shield Dust Shield Guide Pin Strut,AnchorPin Bushing, Brake Shoe Nut, Anchor Pin Lkwshr, Anchor Pin Cam Spring Washer, Cam Pin Cam Pin Lkwshr, Brake Cylinder Bolt, Brake Cylinder 1
2
2
4
8
2
1
1
4
1
2
2
2
2
2
2
2
2
CUIRK
MICHIGI111
EQUIPMENT
BRAKE ASSEMBLY
Item
No.
Part
No.
A
106816
Brake Ass'y. (Inc. all following items)
1
106824
Brake Shoe Assembly (Inc. 1A, 1B
Description
No.
Req'd.
&16) Item
No.
2
REAR
Part
No.
Description
No.
Req'd.
7
100877Pin, Guide 8
100865 Spring, Brake Shoe Adj. Cam 4
4
1-05fec. LIgshrer Mtg..
4
4
4
10
1C-510Bolt, Cylinder Neg. 48
11
101012 Pin, Brake Shoe Adj. Cam 4
Cylinder, Brake (Inc. 2A) 2
12
100867Washer, Brake Shoe Adj. Cam Pin 4
2A 853402
tConnector Link, Brake Cylinder 4
13
6E-12Lkwshr, Anchor Pin 4
2B 853405
$Brake Cylinder Repair Kit 4
1A 106823
Lining, Brake 1B 106184
Rivet,Brake Lining 2
102488
4
14
2D-12Nut, Anchor Pin 100879
Spring, Release 2
15
106817Brake Disc Ass'y. (Inc. 4, 8, 11 & 12) 2
4
100864
Cam, Shoe Adjusting 4
16
102497Bushing, Brake Shoe 4
5
102322
Washer, Guide Pin 8
17
102498Pin, Anchor 4
6
100878
"C" Washer, Guide Pin 4
18
100613 "C" Washer, Anchor Pin .. 4
3
— As Required
PM 1188
[94
]
CUIRK
EQUIPMENT
CONSTRUCTION
MACHINERY DIVISION
micHicnn
BRAKE CONTROLS
Model 75A
Item
No.
1
lA
2
3
4
5
6
7
8
9
Part
No.
Description
552373
Master Cylinder 869449 tRepair Kit, Master Cylinder 8D-07
Nut, Clevis Jam 4F-08127 Pin, Clevis 1F-412
Cotter,ClevisPin Bushing, Brake Pedal Mtg. 551373
Brake Pedal Ass'y. (Inc. 5) 550292
Bolt, Shaft Retaining 2C-640
2D-06
Nut, Shaft Retaining Lkwshr, ShaftRetaining ...... .
4E-06
No.
Req'd.
1
2
t --Not Illustrated
— As Required
PM 1188
95
Item
No.
Part
No.
Description No.
Req'd.
1
10
550299
Shaft, Brake Pedal
11
11H-15
1
12
550301
Fitting, Brake Pedal Grease Spring, Pedal Return 13
14
552377
2C-760
Clevis, Master Cyl. Push Rod Bolt, Master Cyl. Mtg. 1
15
2D-07
1
16
17
4E-07
1C-614
Nut, Master Cyl. Mtg. Lkwshr, Master Cyl. Mtg. 1
18
4E-06
tBolt, Master Cyl. Mtg. t Lkwshr, Master Cyl. Mtg 1
1
1
CLARK
EQUIPMENT
MICHIG1111
PARKING BRAKE CONTROLS
ItemPart
No.No.
No,
Req'd.
Description
ItemPart
No.No.
Description No.
Req'd.
12D-05
Nut, Lever Mtg. 4
15A 2C-616
Bolt — MODEL 75R — GAS
1
24E-05
Lkwshr, Lever Mtg. 4
15B2C-616
Bolt — MODEL 75R — DIESEL ... .
2
32C-524
Bolt, Lever Mtg. 4
16551689
Cable & Conduit Assy. R.H. —
4551742
Parking Brake Lever 1
54F-06106
Pin, Clevis 2
61F-312
Cotter, Clevis Pin 2
74J-6208
Clevis
2
88D-06
Nut, Clevis Jam 2
91C-510
Bolt,Bracket 104E-05
11104645
122D-06
Nut — MODEL 75A & B
4
12A 2D-06
Nut — MODEL 75R 3
134E-06
Lkwshr — MODEL 75A & B 4
13A 4E-06
Lkwshr — MODEL 75R
3
14551834
Clip — MODEL 75A & B
2
14A551834
ClipMODEL 75R 4
152C-616
BoltMODEL 75A & B
3
MODEL 75A & B 16A 551746
Cable & Conduit Assy. — R.H. —
MODEL 75R 1
174F-04051
Pin, Clevis 2
4
18619016
Washer 2
Lkwshr, Bracket 4
191F-208
Cotter
2
Bracket, Conduit ,Mtg
2
20551696
Retainer
21551837
Bracket — MODEL 75A & B .
1
222C-610
Bolt 1
23551688
Cable & Conduit Assy. — L.H. —
MODEL 75A & B 23A 551745
[
96]
1
1
Cable & Conduit Assy — L.H. —
MODEL 75R PM 1188
1
1
CU IRK
EQUIPMENT
MICHIG1111
MACHINERY DIVISION
CONSTRUCTION
1
9
■
10
11
12
13
34
14
P
33
0
E
32
15
31
30
J
29
28
TS - 142-P
19181116
21 2625 24 23 22 21 20
BRAKE LINES AND FITTINGS
Model 75A
Item
No.
Part
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
552384
62F-3
6H-4
550310
620238
552383
107014
613750
620235
620238
692722
550405
550406
550404
613750
552264
552382
PM 1188
Description No.
Req'd.
Brake Line, Master Cyl. to Rear Axle
Elbow, Master Cyl. to Trans. Clip,Brake Line Transmission — See Index
Bolt, Master Cyl. Fitting Copper Gasket, Outer Master Cyl..
Brake Line, Master Cyl. to Front Axle
Wheel Cylinder, Front Axle.. ...
Copper Gasket, Inner Wheel Cyl..
Fitting, Wheel Cyl. Copper Gasket, Outer Wheel Cyl..
Bolt, Wheel Cyl. Fitting Brake Line, Front Axle — L.H. Tee, Front Axle Brake Line, Front Axle — R.H..
Master Cyl. — See Index
Copper Gasket, Inner Master Cyl..
Fitting, Master Cyl. Brake Line, Master Cyl. to Trans.. .
Item
No.
1
1
1
20
21
22
23
24
1
1
1
2
2
2
2
2
1
1
1
Part
No.
8D-10
550324
552374
550325
8D-10
25
518173
552387
26
27
28
29
30
31
32
33
34
[ 97 ]
102488
613750
620235
620238
692722
8D-10
552385
550320
552386
Description No.
Req'd.
Nut, Brake Hose Hose, Frame to Axle Hose, Rear Axle Brake Clip, Axle Brake Hose Nut, Brake Hose 1
1
2
2
2
Brake Line, Frame to Wheel Cyl.. . .
ForSerial10593thru10640&
10643 thru 10648
For Serial 8610 thru 10592, 10641,
2
Wheel Cyl., Rear Axle Copper Gasket, Inner Wheel Cyl...
Fitting, Wheel Cyl. Copper Gasket, Outer Wheel Cyl..
Bolt,Fitting Nut, Brake Hose Brake Line, Rear Axle — R.H Tee, Rear Axle Brake Line, Rear Axle — L.H. 2
2
2
2
2
2
1
1
1
.
CUIRK
EQUIPMENT
MICHIGI111
BRAKE CONTROLS AND LINES
For Serial:
75A — 8123 Thru 8609
75R7123 and Thereafter
Item
No.
Part
No.
Description
1550402
2550403
Brake Line, Master Cyl. to Trans Brake Line, Master Cyl. to Axle Tee
— 75A & B only Brake Line, Master Cyl. to Axle Tee
— 75R only Omit (Part of Item 4)
Clevis & Nut Assembly (Inc. 18). ..
Pin, Clevis Cotter,ClevisPin 2A 550407
3
4940356
54F-08127
61F-412
7550405
8550406
9550404
10550292
112C-640
12550299
134E-06
No.
Req'd.
Brake Line, Axle — L.H
Tee, Axle Brake Line, Axle — R.H Brake Pedal Assembly (Inc. 15).. .
Bolt, Shaft Retaining Shaft, Brake Pedal Lkwshr, Shaft Retaining ItemPart
No.No.
1
1
1
No.
Req'd.
142D-06
Nut, Shaft Retaining 1
15551373
Bushing, Brake Pedal Mtg 2
1611H-15
Fitting, Brake Pedal Grease 1
17550301
Spring, Pedal Return 1
188D-07
Nut, Clevis Jam 1
192C-652
Bolt, Master Cyl. Mtg. 2
202D-06
Nut, Master Cyl. Mtg. Lkwshr, Master Cyl. Mtg. 2
22550985
Master Cyl. Assembly 1
22A 940129
tRepair Kit, Master Cyl. 214E-06
. 1.
— As Required
PM 1188
Description
1 98 ]
23620238
Copper Gasket, Inner Master Cyl 24550309
Fitting, Master Cyl. 25513750
Copper Gasket, Outer Master Cyl 26550310
Bolt,Fitting 2762F-3
Elbow — 90°
2
CUIRK
EQUIPMENT
NOTES
PM 1188
[ 99
MICHIG1111
1011-121314151617-1819-2021
0
0
n
z
0
33 32-31-302928212625242322
TS-139-P
a
INSTRUMENT PANEL ASSEMBLY
CU IRK
EQUIPMENT
C ONSTRUCTION MACHINERY DIVISION
mICHIGpn
INSTRUMENT PANEL ASSEMBLY
ItemPart
No.No.
1
No.
Description
Instrument Panel
Req'd.
ItemPart
No.No.
1
18 12E-10 Lkwshr, Sender Terminal 4
Des'cription
No.
Req'd.
1912D-8Nut, Ignition Terminal.........8
550733For Serial:
20 12E-8Lkwshr, Ignition Terminal
75B — 6123 thru 6200
21
626530Clamp, Instruments 4
22 550775Plug Button — GAS 1
4
22A 600259Push Button, Glow Plug — DEISEL 75B — 6201 & thereafter
23 600259Push Button, Starter 2 2C-710Bolt, Panel to Shroud 24 550746Wire, lgn. Switch to Starter Button
2A 2C-616Bolt, Panel to Shroud 1
—GAS 3 4E-07 Lkwshr, Panel to Shroud 3
24A 552938 Wire, Ign. Switch to Starter & Glow
3A 4E-06Lkwshr, Panel to Shroud 1
Plug Buttons — DIESEL 1
3B
2D-06
Nut, Panel to Shroud
1
25 552935 Wire, Light Switch to Instruments 4
551320
Gauge, Fuel
1
26 550744Wire, Ammeter to Ign. Switch 5
602350
Terminal Separator, Fuel Gauge.. 1
6
550735
Ammeter
27
Ignition Switch 550740For Serial:
1
7
601212
Clamp, Ammeter
8
14D-10
Nut, Ammeter Terminal 4
9
12E-10
Lkwshr, Ammeter Terminal
10
551503
Dash Lamp
11
18G-606
Screw, Dash Lamp 12
12E-6
Lkwshr, Dash Lamp 13
551321
Gauge, Torque Cony. Temp. 1
14
551319
Gauge, Oil Pressure 15
602350
Terminal Separator, Oil Pressure
75B — 6123 thru 6200
1
75B — 6201 & thereafter
2
28 611074Fuse, lgn. Switch to Light Switch . 1
29 552946 Wire, Ign. Switch to Light Switch. 1
Gauge 16
551322
Gauge, Engine Temperature
17
14D-10
Nut, Sender Terminal PM 1188
30 550741Light Switch 1
31 550742 Rod, Light Switch
1
1
32 550743Bushing, Light Switch 8
[
33 661555Fuse, Light Switch to Instruments. 1
101 ]
CUIRK
EQUIPMENT
rmcincon
BATTERY, HOLDER, WIRING AND PARTS
Item
Part
No.
No.
Description
No.
I tern
Part
Req'd.
No.
No.
1
550842
Battery — GAS
2
550360
Battery — DIESEL
3
4
550843
550858
Box, Battery — GAS Box, Battery-- DIESEL 2
20
2C-616
2
21
4E-06
5
2C-612
Bolt, Battery Box to Frame 4
6
2D-06
Nut, Battery Box to Frame 4
7
4E-06
Lkwshr, Battery Box to Frame 4
8
550844
550859
Battery Hold Down — GAS Battery Hold Down — DIESEL 2
9
10
600183
Stud, Battery Hold Down 4
11
619019
12
4E-05
Lkwshr, Battery Hold Down Stud..
13
1 D-05
Nut, Battery 14
15
550845
16
17
550860
25
553145
26
552380
26A 552380
Bolt, Ground Cable Lkwshr, Ground Cable Nut, Ground Cable Wiring Harness — For Units with
Solenoid Starter — GAS WiringHarnessForUnitswith
MechanicalStarter — DIESEL ..
Wiring Ha rness — For Units with
SolenoidStarter — DIESEL ..
2
Clip, Wiring Harness 4
27
552381
28
2C-652
Bolt, Clip to Valve Cable, Battery to Ground 29
2D-06
550846
554016
Cable, Battery Connector 30
4E-06
Nut, Clip to Valve Lkwshr, Clip to Valve Cable, Battery to Solenoid 31
550850
WiringHarness,Gen.toVoltage
550847
Cable, Solenoid Switch to Starter —
32
550851
Reg. Wire, Light Switch to Head Lamp.
33
550852
Wire, Fuel Gauge to Tank Unit...
34
550854
Wire, Steering Column to Horn Relay
35
550855
Wire, Horn Relay to Horn 553466
1
Cable, Starter to Magnetic Switch—
1
1
550848
Cable, Engine to Ground 3
Clip, Wiring Harness — GAS Clip, Wiring Harness — DIESEL..
4
DIESEL 19
24
Req'd.
12
GAS
18
2D-06
553144
2
4
Washer, Battery Hold Down Stud.
22
23
No.
Description LIGHTS AND MOUNTINGS
Item
Part
No.
No.
1
551510
Description No.
Item
Part
Req'd.
No.
No.
No.
Req'd.
Description
12
1 D-05
13
551281
Nut, Plate to Grille Head Lamp Assembly (Inc. 14).
2
2, 3, 5, 6, 7 & 8) 14
551242
Sealed Beam Unit, Head Lamp.
2
Light Mounting Plate Assembly (Inc.
2
2
3
550880
Light Mounting. Plate 551284
Back Up Lamp Assembly (Inc. 4). .
2
15
3G-808
Screw, Ground Wire 2
4
551243
Sealed Beam Unit, Back Up Lamp.
2
16
13E-8
Lkwshr, Ground Wire 2
2
17
12D-8
550882
Nut, Ground Wire Tail Lamp Assembly 2
18
2
5
550745
Wire, Back Up Lamp Ground 6
550853
Wire, Back Up Lamp Jumper 7
8
12D-8
12E-8
Nut, Lamp to Plate Lkwshr, Lamp to Plate 6
19
551314
Bracket, Tail Lamp Mtg. 6
Bolt, Bracket to Grille 4
1C-510
Bolt,PlatetoGrille 4
20
21
1C-610
9
4E-06
Lkwshr, Bracket to Grille 4
10
1C-520
Bolt, Plate to Grille 1D-04
Nut, Lamp to Bracket 4
4E-05
Lkwshr, Plate to Grille 2
6
22
11
23
4E-04
Lkwshr, Lamp to Bracket 4
2
TOOLS
ItemPart
No.No.
Description
No.
Item
Part
Req'd.
No.
No.
No.
Description
Req'd.
1553412
Wrench, Wheel 1
5
552166
Pliers 1
2552164
Handle, Wheel Wrench 1
6
552167
Screwdriver 1
3552172
Wrench, Hub Bearing Hammer 1
7
551971
Grease Gun
1
1
8
552171
Tool Bag 4552165
PM 1188
[ 102]
1
CUIRK
EQUIPMENT
MICHIG1111
Model 75A
WHEEL ASSEMBLY AND TIRE DATA — TUBELESS
Grader Lug
14:00 x 24
8 PR.
1Wheel Assembly — Complete
2Wheel Disc and Rim Base
3Lock Ring
4Flange
5"0" Ring
6Tire
7Valve Stem — For Serial 8123 thru 10718
7A Valve Stem — Effective with Serial 10719
& thereafter
8Valve Stem Adaptor
9Valve Cap
10Wheel Nut
Sure Grip
Grader
14:00 x 24
12 PR.
Rock Lug
14:00 x 24
12 PR.
No.
Req'd.
942478
942485
941325
941326
941329
511847
941422
942478
942485
941325
941326
941329
554023
942478
942485
941325
941326
941329
554071
941422
4
4
4
4
4
4
4
517963
551684
551685
103522
517963
551684
551685
103522
517963
551684
551685
103522
4
4
4
40
Model 75A
WHEEL ASSEMBLY AND TIRE DATA — WITH TUBE
11Wheel Assembly — Complete
12Wheel Disc and Rim Base
13*Lock Ring
14Tire
15Tube
16Wheel Nut
Grader Lug 13:00 x 24
8 PR.
Rock
Grader Lug
13:00 x 24
16 PR.
940375
552696
552602
550258
550259
103522
940375
552696
552602
552041
550259
103522
940375
552696
552602
550278
550158
103522
4
4
8
4
4
40
551541
551542
551541
551542
4
4
Ground Grip
Road Builders
13:00 x 24
8 PR.
No.
Req'd.
Grader Lug
14:00 x 24
8 PR.
No.
Req'd.
*For machines equipped with Firestone Rims, this item as follows:
13Lock Ring
13A Side Ring
551541
551542
Models 75B and 75R
WHEEL ASSEMBLY AND TIRE DATA — WITH TUBE
75B
Truck Type
9:00 x 16 8 PR.
75R
Heavy Duty
Transport
9:00 x 20
10 PR.
17Wheel Assembly — Complete 18Wheel Disc and Rim Base
1 9Side Ring
940376
551111
552650
941621
941480
941481
20Lock Ring
21Tire
22Tube
23Flap
24Wheel Nut
551114
551115
551116
103522
550266
550267
550268
103522
940375
552696
103522
2
2
2
4
2
2
2
20
551541
551542
4
4
* *552602
550258
550259
**For machines equipped with Firestone Rims, this item as follows:
20Lock Ring
20A Side Ring
PM 1188
[ 103 ]
.
n
0
z
iff
C
0
In
0
z
CUIRK
EQUIPMENT
MICHIG1/11
FLOORBOARD, HORN AND FUEL TANK ASSEMBLY
Part
Item
No.
Description No.
No.
Req'd.
Floorboard Assembly — Rear 1
550626
1
For Serial:
75A8123 thru 8609
Item
No.
No.
Lkwshr, Tie Strap to Mtg. Strap...
2
29
2D-06
Nut, Tie Strap to Mtg. Strap 2
Bolt, Fuel Tank to Frame 4
2C-832
For Serial:
75A — 8123 thru 10557
75B — 6123 thru 6210
2
4E-06
Lkwshr, Floorboard to Frame 3
3
1C-612
Bolt, Floorboard to Frame 3
Floorboard Assembly — Front 1
5
75R — 7123 thru 7157
2C-828
Effective with Serial: 75A — 10558 and thereafter
550748
Mechanical Starter
75B.— 6211 and thereafter
550631
Solenoid Starter
14D-10
Nut, Bumper Mtg. Pad, Fuel Tank to Frame 31
13E-10
Lkwshr, Bumper Mtg. 7
2D-06
Nut, Horn to Floorboard 75A — 8123 thru 10557
8
4E-06
Lkwshr, Horn to Floorboard 75B — 6123 thru 6210
9
302568
Bumper, Brake Pedal Return Stop.
6
No.
Req'd.
4E-06
4
Description 28
30
552375
Part
550711
2
For Serial:
75R — 7123 thru 7157
518233
10
616775
Washer, Bumper Mtg. 11
2G-1010
Screw, Bumper Mtg. 75B — 6211 and thereafter
12
647300
Horn
13
2C-612
Bolt, Horn to Floorboard 32
21D-08
Nut, Fuel Tank to Frame 2
14
2C-616
Bolt, Tank Mtg. Strap to Shroud..
33
2C-616
Bolt, Tie Strap to Mtg. Strap 2
15
103293
Washer, Tank Mtg. Strap to Shroud
34
621279
Bracket, Horn Mtg. 1
16
2D-06
Nut, Tank Mtg. Strap to Shroud...
35
647310
Relay, Horn 1
17
4E-06
Lkwshr, Tank Mtg. Strap to Shroud .
36
4E-04
Lkwshr, Horn Bracket to Horn 2
18
517616
Mounting Strap, Fuel Tank 37
2D-04
Nut, Horn Bracket to Horn 2
19
551384
Fuel Gauge, Tank 20
14D-10
38
2D-06
Nut, Floorboard to Bracket 2
Nut, Fuel Gauge Terminal 21
12E-10
Lkwshr, Fuel Gauge Terminal 39
4E-06
Lkwshr, Floorboard to Bracket 2
22
3G-1008
Screw, Fuel Gauge to Tank 40
2D-06
Nut, Bracket to Frame 2
23
627982
Gasket, Fuel Gauge to Tank 41
4E-06
Lkwshr, Bracket to Frame 2
24
4H-54
Clamp, Fuel Filler Hose 42
550632
Bracket, Floorboard Support 2
25
550712
Hose,FuelFiller 43
2C-620
Bolt, Bracket to Frame 2
26 *517073
Fuel Tank Assembly 44
2D-06
Nut, Floorboard to Frame 6
26A 942424
Fuel Tank Mtg. Kit (Inc. Items 14 thru
45
4E-06
Lkwshr, Floorboard to Frame 6
27517617
18 & 27 thru 33) 1
46
2C-616
Bolt, Floorboard to Bracket 2
Tie Strap, Fuel Tank 1
47
2C-616
Bolt, Floorboard to Frame 6
*For Machine Serials listed below, use Item 26A when
installing #517073 Fuel Tank.
75A — 8123 thru 10557
75B6123 thru 6210
75R — 7123 thru 7157
PM 1188
[ 105]
CLARK
EQUIPMENT
0)11111 111111
MICHIGIM
1111 111. 1
MECHANICAL STARTER PEDAL AND LINKAGE
No.
Item
Part
Req'd.
No.
No.
No.
Item
Part
No.
No.
1
1F-310
Cotter, Start Rod to Starter Pin .
1
11
4C-844
Bolt,Lever Mtg. 1
2
552323
Spring, Start Lever Return 1
12
4F-08127
Pin, Clevis to Start Lever 1
3
1F-414
Cotter, Start Rod to Start Lever....
13
4J-8300
Clevis, Start Rod to Start Lever 1
4
2D-08
Nut, Start Lever Mtg. 1
14
8D-08
Nut, Clevis Jam 1
5
4E-08
Lkwshr, Start Lever Mtg. 1
15
552039
Rod, Start 1
6
550646
Sleeve, Start Lever Mtg. 1
7
551373
Bushing, Start Lever Mtg. 1
8
550796
Start Lever Ass'y. (Inc. Item 7). .. .
1
9
12H-15
Fitting, Start Lever Grease 1
10
616795
Washer, Start Lever Mtg. 1
Description 15A 550799
Description Start Rod Assembly (Inc. 13,14 &
15)
PM 1188
16
17
106)
4F-06106
Req'd.
Pin, Start Rod to Starter Starter — See Index
1
MARK
EQUIPMENT
MICHIGI/11
ETHER START PANEL ASSEMBLY
Item
Part
No.
No.
Description No.
Item
Part
Req'd.
No.
No.
No.
Description
Req'd.
1
51F-1
Elbow, Pump to Manifold 1
10
2C-616
Bolt, Start Panel Mtg.
2
2
6H-2
Clip, Tube to Engine 1
11
4E-06
Lkwshr, Start Panel Mtg.
2
3
1C-608
Bolt, Clip 2
12
2D-06
Nut, Start Panel Mtg.
2
4
4E-06
Lkwshr, Clip 2
13
551902
Clip, Shut Off Cable
1
5
551253
Tube, Ether 1
14
6
551022
Cable,Shut Off 1
15
553664
tClip, Shut Off Cable
1
7
550750
StartPanel
1
16
2G-1008
f Bolt, Clip
2
8
940150
Puncturing Tool, Ether Capsule 1
17
17E-10
flkwshr, Clip
2
9
940151
Pump, Ether Priming 1
18
14D-10
tNut, Clip
2
PM 1188
[ 107]
Fuel Injection Pump — See Index
CUIRK
EQUIPMENT
NOTES
PM 1 188
[ 1081
mICHIGAn
CUIRK
EQUIPMENT
mICHIGpII
NUMERICAL INDEX
Part No.
Description
Page No.
Bearing 49, 51
B-2420
45, 47
M 903310 Cup M 903345 Cone 45, 47
SK 203-96 Bearing 25, 26, 27
SK 203-97 Bea ring 25, 26
26
SK 203-98 Bearing 26
SK 203-99 Bearing 49
SK 250-27 Ring 27, 28
SK 250-30 Ring 26
SK 250-63 Ring 27, 28
SK 250-74 Ring SK 250-91 Ring 25, 26
SK 250-93 Ring 31
SK 251-23 Ring 41, 53
SK 251-26 Ring 26
25, 26
SK 251-63 Ring SK 251-64 Ring 27, 28
SK 251-90 Ring 31
SK 251-92 Ring 25, 26
T-75A1
25
Transmission Assy
T-75A3
Transmission Assy
25
T-75B1
Transmission 28
T-75B2
28
Transmission T-75R1
Transmission 28
T-75R2
Transmission 28
T-138
Bearing 43
T-151
Bearing 49, 51
Bolt 17
1 C-409
1C-410
Bolt 2, 22
1C-416
Bolt 19
1C-510
Bolt 94, 96,102
1C-512
Bolt 1,15
IC-516
Bolt 1,3
1C-520
Bolt 102
1 C-608
Bolt 107
1C-610
Bolt 93, 102
1 C-61 2
Bolt 27, 45
47, 65, 105
Bolt 25, 26, 27
1C-614
51, 54, 95
27
1C-616
Bolt 2
1C-618
Bolt 1 C-620
3, 87
Bolt 1C-626
31
Bolt 1C-628
Bolt 3
1C-718
Bolt 25, 26
27, 31, 65
27, 41
Bolt 1C-720
45, 47, 53
41, 45
1C-722
Bolt 47, 53, 57
1C 726
Bolt 65
41, 45
Bolt 1C-728
47, 53, 57
Bolt 41,45, 47, 53
1 C-808
1
1 C-824
Bolt 1C-828
57
Bolt 1C-832
73
Bolt 1C-928
Bolt 57
49, 51
1C-' 048
Bolt 12
1C-1072
Bolt 1 D-04
Nut 19, 22,102
102
1D-05
Nut 1 D-08
Nut 73
PM 1188
Part No.
Description
Page No.
12
Nut 17,18
Cotter Cotter 17,18,31,96
Cotter 17, 59, 60,106
96
Cotter 17,18,81
Cotter 95, 98
Cotter 12, 59
Cotter 60, 90, 106
43, 49, 51
Cotter 1F-416
Cotter 25, 45, 47, 67,
1F-424
69, 72, 77
78, 79, 80
72
Cotter 1F-426
Cotter 49, 51, 57, 67
1 F-428
27, 74
1 F-432
Cotter 43
1F-628
Cotter 51, 54
Cotter 1F-632
91, 92
1F-648
Cotter 6, 67, 69
1 F-848
Cotter 93
Rivet 1H-410
15
1M-16050 Hose 15,17,18
2C-410
Bolt 2
2C-412
Bolt 2
2C-414
Bolt 58
2C-424
Bolt 17,18
2C-448
Bolt 2
2C-510
Bolt 19, 21
Bolt 2C-512
62, 63
2C-514
Bolt 17, 79
2C-516
Bolt 2, 96
2C-524
Bolt 9, 96
Bolt 2C-610
62
Bolt 2C-612
63,102,105
9,18
Bolt 2C-616
19,21,22
83, 96,101
102,105,107
2,9,13
Bolt 2C-620
21,62, 63
86, 87, 105
9
Bolt 2C-622
76, 78, 80
Bolt 2C-624
95, 98
Bolt 2C-640
10,11
Bolt 2C-648
98,102
Bolt 2C-652
11,82
Bolt 2C-656
7,11
Bolt 2C-672
101
Bolt 2C-710
95
2C-760
Bolt 83
Bolt 2C-820
9
2C-824
Bolt 13, 77, 78
2C-828
Bolt 79, 80,105
Bolt 1, 65, 72,105
2C-832
9, 49, 51
2C-836
Bolt 12
Bolt 2C-840
12, 60
2C-844
Bolt 91, 92
2C-852
Bolt 5, 89
2C-856
Bolt 59, 90
2C-868
Bolt 91
Bolt 2C-872
10
Bolt 2C-876
1D-10
1F-207
1F-208
1F-310
1F-312
1F-316
1F-412
1F-414
[
N1 ]
Part No.
Description
2C-1018
2C-1040
2C-1044
2C-1052
2D-04
Bolt
Bolt
Bolt
Bolt
Nut
2D-05
Nut 2D-06
Nut 2D-07
2D-08
Nut Nut 2D-09
2D-10
Nut Nut 2D-12
Nut 2E-04
2E-06
2G-1008
2G-1010
2G-1014
2G-1210
2J-4200
2J-10109
3E-07
3E-08
3G-808
3G-1008
4C-616
4C-844
4D-06
4D-12
4D-14
4D-16
4D-20
4D-24
4E-04
Lkwshr Lkwshr Bolt Screw Screw Screw Yoke Clevis Lkwshr Lkwshr Screw Screw Bolt Bolt Nut Nut Nut Nut Nut Nut Lkwshr 4E-05
Lkwshr 4E-06
Lkwshr Page No.
21
73
27
9
2,15,17
18,58,105
2,17
19,21, 62
63, 79, 96
2,3,7,9,10
11,13,18
19,21,22
43, 49, 51
62, 63, 76
78, 80, 82
86, 87, 95
96, 98,101
102,105,107
69, 95
5, 10, 12
27, 41, 49
51, 53, 59
60, 65, 72
77, 78, 79
80, 83, 90
91, 92,106
45, 47
9, 27, 45
59, 60, 73
5, 6, 7
9, 93, 94
3
65
107
105
9
3
17
17
65
41, 45, 47, 53
102
105
91, 92
59, 106
81
73
69
43
51, 54
6
2,15,17
18,19,22
58,102,105
1,2,15
17,19,21
62, 63, 79
94, 96,102
2,3,7,9,10,
11,13,18
19,21,22
25, 26, 27
43, 45, 47
49, 51, 57
58, 59, 62
63, 75, 76
CUIRK
EQUIPMENT
Part No.Description
4E-06 (Continued)
4E-07
4E-08
4E-09
4E-10
4E-12
4F-03038
4F-04051
4F-06106
4F-08127
4H-15
4H-30
4H-35
4H-38
4H-54
4J-4200
4J-6208
4J-8300
5K-207
5K-432
6D-14
6E-06
6E-12
6H-1
6H-2
6H-4
6H-9
6H-16
6J-404
6J-405
7D-08
7E-08
7J-3108
8D-04
8D-06
8D-07
8D-08
8D-10
8D-14
10H-2
10H-25
10H-35
10J-09
10110
10J-12
11D-08
11F-12
11H-1
11H-15
Page No. 1
77, 78, 79
80, 83, 86
87, 93, 95
96,98,101
102,105,107
25
Lkwshr 27,31,41
45, 47, 53
57, 95,101
Lkwshr 1,5,9,10
12, 41, 49
51, 53, 57
59, 60, 65
72, 73, 77
78, 79, 80
83, 89, 90
91,92,106
45, 47, 57
Lkwshr Lkwshr 9,12,27
45, 49, 51
59, 60, 73
93
Lkwshr Pin 17,18
Pin 17,1'8,96
Pin 59, 60, 96,106
12
Pin 59, 60, 90
95, 98,106
15
Clamp 13
Clamp 15
Clamp 15
Clamp 105
Clamp 18
Yoke Clevis 96
12, 59
Clevis 60, 90,106
Nipple 19, 62, 63
Extension
65
Nut 67
Lkwshr 31,51,54
94
Lkwshr Clip 19
Clip 107
Clip 97
Clip 19,22
Clip 62, 63
Key 81
Key 1
51
Nut Lkwshr 41, 45, 47, 53
43
Key Nut 17,18
Nut 58, 59, 89, 96
Nut 65, 95, 98
12,59
Nut 60, 90,106
97
Nut Nut 57
Fitting 6, 7, 67, 69, 74
10,11,43
Fitting 45, 47, 61
72, 77, 78
79, 80, 92
10
Fitting 65
Ball Ball 82, 84
Ball 27, 28
31, 55, 67
49
Nut 83
Plug 49, 51
Fitting Fitting 7,10
72, 95, 98
PM 1188
Part No.
Description
12D-8
12E-6
12E-8
12E-10
12F-110
12F-200
12F-204
12H-15
12J-12
13E-8
13E-10
13F-02
13F-04
13F-12
Nut 101,102
Lkwshr 101
Lkwshr 101,102
Lkwshr ....9,21,101,105
43
Plug Plug 49, 51
Plug 45, 47
Fitting 12,59,60,106
Ball
69
Lkwshr 102
Lkwshr 9,105
Plug
31
Plug 22,27, 62, 63
27, 41
Plug 45, 47, 53
Screw 49, 51
Bolt 27
Nut 9,17,21
101,105,107
Nut
3
Plug 45, 47
Plug 41, 45, 47, 53
Screw 69
Fitting 49,51
Fitting
5
69, 82
Plug 69
Plug
Plug
89
Plug
89
Plug
89
Plug 89
Nut 67
Lkwshr 107
Screw 67
58
Nut Nut 67, 69
19
Tee 101
Screw Reducing Bushing
19
Reducing Bushing 21
Bushing 27
27
Bushing Nut 1, 13,57,105
Clamp 76, 78, 80
65
Cap Adaptor Union 86
"0" Ring 69
"0" Ring 25, 26
31, 67, 69
Ring 67
Ring 67, 69
Ring 69
Ring 87
Ring 91, 92
Ring 89
Ring 67, 69
Ring 67, 69
Ring 91, 92
Ring 83
62, 63
Elbow 63
Elbow 62, 63
Tee 21
Elbow 62, 63
Tee AdaptorUnion-_19, 62, 63
Adaptor Union 62
13G-820
14C-840
14D-10
14D-12
14F-04
14F-12
15G-612
15H-1
15H-15
16F-02
16F-04
16F-06
16F-08
16F-12
16F-16
17D-6
17E-10
17G-416
18D-05
18D-06
18F-2
18G-606
19F-1
19F-3
19F-8
19F-16
21D-08
21H-24
22F-4
25F-7
25K-20010
25K-30016
25K-30018
25K-30020
25K-40028
25K-40110
25K-40112
25K-40116
25K-40204
25K-40216
25K-40416
25K-40428
26F-5
26F-6
28F-1
29F-1
30E-1
31F-2
31F-4
Page No.
75, 76, 77
31F-5
31F-7
33F-5
36F-5
36F-6
78, 79, 80
AdaptorUnion_.62, 86, 87
Adaptor Union 86
Adaptor Union 86, 87
AdaptorUnion 62
63, 86, 87
Adaptor Union 63
[N2]
mICHIGAfl
Part No.
Description
51F-1
59F-2
59F-6
62F-2
62F-3
62F-4
62F-5
62F-6
69F-4
69F-5
73F-2
83F-6
83F-7
83F-8
84F-7
85F-8
89F-7
91F-5
91F-6
Elbow 107
Connector 19
Connector 19,21
Elbow 19
Elbow 97, 98
Elbow 2
Elbow 19,21
Elbow 21
Valve 22
Valve 19,21
Drain Cock 13
Elbow 62
Elbow 62, 63
Elbow 63
Elbow 62, 63
Elbow 63
Connector 62, 63
Seal 69
"0" Ring 75, 76, 77
78, 79, 80
63
Reducing Bushing 54
Cup 54
Cone 51, 54
Cup 51, 54
Cone 54
Cup 54
Cone 49, 51
Cup 49, 51
Cone Cup 51, 54
51, 54
Cone 57
Cone 57
Cup Cup 41; 45, 47, 53
Cone 41, 45, 47, 53
Cup 41, 45, 47, 53
Cone 41, 45, 47, 53
57
Cone 57
Cone 57
Cup 57
Cup Diff. Body Sub Assy
57
57
Pinion 57
Gear 57
Spider 57
Washer 57
Washer 57
Bolt 57
Bolt 25, 26
Bolt 47
Clip 49, 51
Cap 49, 51
Nut Washer 49, 51
94
"C" Washer Nut 49, 51, 73
93, 94
Cam Spring 93, 94
Washer 93, 94
93
Bushing 94
Pin "C" Washer 93, 94
94
Spring 57
Bolt 57
Cage & Cup Assy
57
Nut 57
Lock 57
Retainer 57
Gasket 57
Seal 57
Gasket 57
Shim 57
Shim 57
Shim 97F-20
532X
539
552A
559
3328
3386
25821
25877
26822
26882
33281
33462
47620
47681
47820
47896
53178
55187
53375
55443
100160
100169
100170
100171
100172
100173
100174
100176
100284
100320
100323
100575
100588
100613
100857
100864
100865
100867
100872
100877
100878
100879
100937
100938
100940
100941
100942
100943
100944
100945
100946
100947
100948
Page No.
CLARK
EQUIPMENT
Part No.
100949
100950
100951
100952
100953
100954
100965
100966
100967
100970
101004
101012
101092
101332
101597
102156
102157
102159
102225
102250
102251
102252
102322
102435
102436
102438
102488
102497
102498
102594
102766
103076
1 03 1 65
103166
103188
103227
103228
103293
103376
103445
103522
103917
103927
103928
103929
103935
103942
103953
103954
104412
104524
104549
104645
104942
105111
106042
106058
106059
106066
106067
106068
106075
106076
106079
106080
106081
106082
106087
106088
PM 1188
Description
Page No.
Shield 25,27, 28, 57
Nut 57
Washer 57
Spacer 57
Screw 57
Lock 57
Nut 41, 45, 47, 53
Nut 41, 45, 47, 53
Lock 41, 45, 47, 53
Bolt 41, 45, 47, 53
Gasket 41, 45, 47, 53
Pin 94
Bolt 41, 53
"C" Washer 93
Oil Throw 41, 53
Hub 54
Oil Seal 54
Cap 54
Bushing 43
Key 43
Washer 51, 54
Shim 43
Washer 93, 94
Retainer 73
Felt 73
Spring 73
Wheel Cylinder 94, 97
Bushing 94
Pin 94
Key 49, 51
Washer 45, 47, 57
Nut 41, 45, 47
51, 53, 54
Clamp 49, 51
Cover 47, 51
Cap 51, 54
Tie Rod End Assy 49, 51
Tie Rod End Assy 49, 51
Washer 9,105
Nut 9
Stud 41, 45, 47
51, 53, 54
Nut 41, 45, 51
53, 54,103
Axle Center Assy
49
Knuckle 49, 51
Knuckle 49, 51
Pin 49, 51
OilSeal 51,54
Shim 49, 51
Felt 49
Cup 49
Washer 41, 47, 53
Dust Shield 93
Washer 45, 47
Bracket 96
Breather Assy 31
Housing 41,53
Diff. Carrier & Cap
Assy. 57
SunGear ._41, 45, 47, 53
Gear 41, 45, 47, 53
Gasket 41, 45, 47, 53
Cap 41, 53
Gasket 41, 45, 47, 53
45
Diff. & Carrier Assy
47, 53, 57
Diff.Assy 57
Retainer 73
Ball Stud 73
Flange 57
Housing Assy 41,53
Shaft 41, 53
Washer 73
Part No.
106091
106092
106093
106094
106095
106096
106097
106099
106100
106101
106102
106103
106106
106108
106109
106110
106111
106112
106113
106114
106115
106116
106117
106119
106120
106121
106123
106124
106125
106127
106128
106129
106130
106131
106132
106133
106134
106135
106136
106137
106138
106139
106140
106141
106142
106143
106144
106145
106146
106147
106148
106149
106158
106160
106162
106163
106164
106165
106166
106167
106179
196180
106182
106183
106184
106185
106216
106313
106319
106320
106321
106322
106335
Description
Page No.
Spring 73
Oil Seal 41, 45, 47, 53
Cap 73
Ring 73
Gasket 45, 47
Axle Shaft & U Joint
Assy 45, 47
Spindle Assy 45
Bushing 45, 47
Support Assy 45, 47
Support Assy 45, 47
Diff. & Carrier Assy..41, 57
Diff.Assy
57
Hub & Cap Assy 45
Tie Rod Assy 45, 47
Tie Rod 45, 47
Tie Rod End Assy
73
Support 45, 47
Support 45, 47
Housing 73
Socket 73
Stud 45, 47
Housing 45, 47
Housing 45, 47
Trunnion 45, 47
Trunnion 45, 47
Retainer 45, 47
Shim 45, 47
Shim 45, 47
Shim 45, 47
Oil Seal 45, 47
Washer 45, 47
Washer 45, 47
Retainer 45, 47
Gasket 45, 47
Seal 45, 47
Seal 45, 47
Spring 45, 47
Retainer 45, 47
Ring 45, 47
Felt 73
Retainer 73
KnuckleAssy 43
Knuckle 43
Knuckle 43
Knuckle 43
Tie Rod Assy 43
Tie Rod 43
Tie Rod End Assy
73
Tie Rod End Assy
73
Housing 73
Housing 73
Axle Center Assy
43
Hub Assy 43, 54
Hub Assy 49, 51, 54
Pin 43
Arm 43
Arm 43
Tie Rod Assy 49, 51
Tie Rod 49, 51
49
Spider Link Support 93
Link Support 93
Spring 73
45, 47
Cap Rivet 93, 94
Spring 93
Spring 93
Bolt 45, 47
Shim 45, 47
Shim 45, 47
Shim 45, 47
Bolt 45, 47
Brake Assy 41, 53, 93
[N3]
DIVISION
Part No.
106336
106337
106338
106342
106343
106344
106346
106347
106348
106349
106350
106351
106352
106372
106373
106454
106455
106526
106539
106656
106735
106762
106790
106793
106814
106815
106816
106817
106820
106821
106823
106824
106879
106880
106969
106970
106998
107014
107256
107447
107449
107450
107451
107461
107608
107609
107611
107612
130048
130049
130056
130064
130144
130148
130151
201120
201566
201844
201951
203647
204432
205928
206864
208760
208773
208775
208776
208777
208805
208807
208809
208810
MICHIG1111
Description Page No.
Brake Assy 41, 53, 93
Brake Disc Assy 93
Brake Disc Assy 93
Hub 51, 54
Hub & Drum Assy____41, 53
Brake Drum 41, 53
Planet Spider Assy....41, 55
Spider 55
Pinion
55
Shaft 55
Washer 55
Roller
55
Spacer
55
Cam Pin 93
Guide Pin 93
Cap Assy 41, 53
Washer 41, 53
Link Assy 93
Bolt 45, 47
Breather Assy 41
45, 47, 53
Bolt 45, 47
Washer 45, 47
Arm 45, 47
Hub & Cap Assy 41
47, 53
Hub & Drum Assy 47
Brake Drum 47
Brake Assy 47, 94
Brake Disc Assy 94
Oil Slinger 47
Spindle Assy 47
Lining
94
Brake Shoe Assy 94
Hub
47
Bolt 41, 45, 47, 53
Pin 93
Strut
93
Nut 47
B rake Cyl. 93, 97
Bolt 41, 47, 53
Axle Center Assy 51
Pin
51
Spider & Cup Assy 51
Steering Spider 51
Seal
51
Clip 41, 53
Axle Kit 49
Brake Shoe Assy. 93
Lining
93
Axle Assy.-R.D.S. 45
Axle Assy.-R.D.S. 47
Axle Assy.-R.D. 53
Axle Assy.-F.D. 4 1
Axle Assy.-R.S. 49
Axle Assy.-F.S. 43
Axle Assy.-R.S. 51
Plug 27
Screw 27, 28
Spring 27, 28
Nut 25
Spring
31
Bolt 57
Nut 27
Oil Seal 25, 27, 28
Plate
25, 26, 27
Disc 25,26, 27
Piston 25, 26
Ring
25, 26, 27
Ring 25, 26
Valve
31
Valve
31
Pin
31
Pin
31
MARK
EQUIPMENT
Page No.i
Part No.
Description
208812
208815
208820
208871
209103
209339
209340
209341
209342
209343
209352
209353
209354
Seal Valve Cup OilSeal Pipe Cap Shim Shim Shim Flange & Deflector Assy.
Cover Gasket Oil Screen &
Frame Assy. Cover Assy. Cover .Assy. 25,
Clutch Group Assy. Cap 25,
25,
Shim Shim 25,
25,
Shim 25,
Shaft 25,
Gear Gasket Gear Gear Gear Gear Gear Cover Gasket Housing Valve Assy. Link 25,
Drum Ring 25,
Spring 25,
25,
Cap 25,
Shim 25,
Shim 25,
Shim Gear & Bshg. Assy Bushing Gear &. Bshg. Assy Bushing Fork Shaft Support Gasket Thrust Washer Shaft Hub Retainer Shim Cap Spacer Flange. & Deflector
Assy. 27,
Cap Shim Shim Shim Gear Shaft Assy. 27,
Bushing 27,
Shaft 27,
Hub Bearing Cap 27,
Gasket 27,
Housing 27,
27,
Plate Gasket 27,
Fork 27,
ShiftRail 27,
209357
209358
209362
209364
209365
209366
209367
209368
209369
209370
209371
209372
209374
209375
209377
209378
209379
209380
209381
209382
209385
209387
209389
209391
209392
209393
209394
209396
209398
209399
209402
209403
209404
209405
209406
209407
209408
209409
209410
209411
209412
209413
209414
209416
209417
209418
209419
209421
209423
209425
209426
209427
209428
209429
209430
209431
209432
209433
209434
PM 1188
31
31
31
27
26
25
25
25
25
25
27
26
26
26
26
27
26
26
26
26
26
26
27
26
26
25
25
25
31
31
31
31
31
26
26
26
26
26
26
26
27
27
27
27
27
27
27
27
27
28
27
28
27
28
28
28
26
26
26
26
26
28
27
28
28
28
.28
28
28
28
28
28
Page No.
Part No.
Description
209435
209673
209690
209692
209701
209702
209703
209709
209874
209878
209894
209928
209932
209937
220363
220395
220539
220541
220542
220543
220669
Oil Seal 27, 28
27
Oil Ring 31
Arm & Shaft Assy
27
Cap 27
Shim 27
Shim 27
Shim Spring 25, 26, 27
31
Ball Stop 31
Stop. 31
Guide 25, 26
Disc Pin 25, 26
Washer 25, 26
31
Spring 26
Gear Hub 25, 26, 27
25, 26
Shaft 25
Shaft 26
Shaft Oil Screen &
26
Frame Assy. 26
Pipe/
Guard 25, 26
25, 26
Shim Gasket 25, 26
25
Transmission Assy.
Knob 58, 59, 60, 90
105
Bumper 103
Tire 18
Rod Assy. Bushing 86, 87
Wheel Disc & Rim Base _103
_101
Instrument. Panel 10
Guide Bar Assy. 17
Clip 17
Rod 17
Bracket Assy. 17
Arm Rod Assy. 17
r
Bucket Cylinder Assy. 92
Cylinder & Bushing Assy. 92
9
Side Panel Assy. 5
Frame Assy. 61
Prop Shaft Assy. 9
Side Panel. Assy. 9
Hood Assy. 9
Hood Assy. 15
Hose 21
Line Assy. 21
Line Assy. Line Assy. 22
PipeAssy. 76
63
Line Assy. 63
Line Assy. 17
Rod Assy. Rod Assy. 17
18
Rod Assy. 18
Rod Assy. 13
Clip Adaptor 91, 92
Adaptor 91, 92
Packing 91, 92
Shim 91, 92
Adaptor Union 76, 78
80, 82
Hose 76, 78, 80
15
Hose 105
Fuel Tank Assy
6
Frame Assy. 7
Frame Assy. 78
Coupling Assy. 80
Pipe Assy. 105
Strap 220673
220678
221208
221401
280071
300208
302568
511847
511945
512108
512127
512468
512991
513002
513003
513005
513007
513008
514166
514167
514226
514265
514268
514427
514428
514429
51 4603
514605
514606
514608
514610
514613
514614
514617
514620
514622
514624
514658
514740
514741
514742
514743
514788
516159
516432
517073
517076
517087
517119
517157
517616
.
[N4]
mIcHICPn
Page . No.
Part No.
Description
517617
517963
518173
518233
550000
550010
550044
550062
550066
550069
550070
550080
550081
550083
550085
550087
550088
550089
550097
550099
550105
550112
550120
550129
550130
550143
550144
550158
550176
550178
550179
550187
550188
550191
550193
550206
550207
550208
550210
550229
550231
550242
550243
550252
550253
550254
550258
550259
550263
550266
550267
550268
550278
550282
550292
550299
550301
550309
550310
550320
550324
550325
550360
550388
550389
550397
550398
550402
550403
550404
550405
550406
550407
550572
TieStrap 105
Valve Stem 103
97
Brake Line Pad 9, 13,105
5
Frame Assy. Bushing 5, 6, 7
65
Clamp 5
Cradle Assy, Bushing 5, 43, 91
Pin 5
Shaft 5, 6, 7
Piston 91, 92
91, 92
Ring 91
Piston Rod Assy 91, 92
Cap Packing Gland 91, 92
Wiper 91, 92
Retainer 91,92
92
Piston Rod Assy. Lockwke 91,92
Frame Assy. 6
7
Frame Assy. 7
Pin Support 58
Boom & Pipe Assy.
10
Bushing 10
10
Pipe Assy. 103
Tube 10
Pipe Assy. 10
Shaft 10
Pin 72
Bell Crank 10
Pin 10
Bushing 11
CarrierAssy. 11
Bushing 10,11
Pin 11
Pin 11
Bucket Assy. 92
Bushing 11
Pin 84
HydraulicPump
81
HydraulicPump 9
Grille Pad 5
Bolt 103
Tire 103
Tube 5,6, .7
Bolt 103
Tire 103
Tube 1,03
Flap 103
Tire ControlValve Assy._ .....89
PedalAssy. 95, 98
Shaft 95, 98
Spring 95, 98
98
Fitting 97, 98
Bolt 97
Tee 97
Hose 97
Clip 102
Battery 83
Cap 83
Cover 83
Gasket 83
ClampRing .98
Brake Line 98
Brake Line Brake Line 97, 98
Brake Line 97, 98
Tee 41, 53, 97, 98
98
Brake Line 27
Bracket Assy. CMRK
EQUIPMENT
Page No.
Part No.
Description
550575
550576
550579
550580
550583
550584
550585
550586
550588
550589
550590
550591
550594
550595
550596
550597
550600
550601
550602
550604
550605
550608
550610
550611
550612
550614
550616
550619
550624
550626
550631
550632
550634
550635
550640
550644
550646
27
Pad 27
Bracket Assy. 61
Prop Shaft Assy. 61
Prop Shaft Assy. 9
Counterweight 9
Bolt Bolt 9
9
Pin Assy. 13
Radiator Clip 13
13
Hose Hose 13
65
U-Bolt Drag Link Assy. 74
Steering Booster Assy.... 67
72
Push Rod Assy.
Bell Crank Assy. 72
Bushing 72
Pin 72
Rod 72
Tie Rod End Assy 72
Hydraulic Line Assy.
75
Tee 75
Tube 75
Coupling 75
Lug 75
Crank Assy. 17,18
17,18
Rod Guide 17,18
Floorboard Assy. 105
105
Floorboard Assy. 105
Bracket Cushion 9
9
Cushion Lever Assy. 90
Lever Assy. 90
Sleeve 12, 59, 60
90, 106
Rod Assy. 90
Muffler 15
Adaptor 15
15
Clamp 15
Cap 15
Air Cleaner Tube Assy. 15
Hose 15
15
Hose 15
Strap Connector 15
Lever Assy. 58
Lever Assy. 58
Plate Assy 58
U-Bolt 58
Rod 58
Ball Socket 58, 59
Lever Assy. 59, 60
Rod Assy. 59, 60
Rod Assy. 59, 60
Lever Assy. 59
Rod Assy. 59
59
Crank Assy. Rod 59
Support Assy. 1
Pad 1
AdaptorUnion..75, 77, 79
Pad 105
Hose 105
Hose 86
Hose 86, 87
Hose 62, 63, 86, 87
Crosspipe Assy. 86, 87
Crosspipe Assy. 86, 87
Instrument Panel 101
Ammeter 101
550647
550650
550651
550652
550653
550654
550655
550657
550658
550659
550660
550663
550667
550669
550672
550674
550675
550677
550679
550683
550685
550687
550689
550691
550697
550698
550700
550711
550712
550718
550723
550724
550725
550728
550733
550735
PM 1188
Part No.
Description
550740
550741
550742
550743
550744
550745
550746
550748
550750
550757
550758
550764
550765
550775
550781
550782
550788
550789
550796
550799
550803
550809
550814
550832
550833
550842
550843
550844
550845
550846
550847
550848
550850
550851
550852
550853
550854
550855
550858
550859
550860
550862
550866
550873
550874
550875
550876
550880
550882
550883
550886
550889
550890
550893
550983
550984
550985
551015
551016
551022
551090
551111
551114
551115
551116
551178
551242
551243
551253
551281
551284
551314
551319
551320
Igition Switch 101
101
Switch 101
Rod 101
Bushing 101
Wire 102
Wire 101
Wire Floorboard Assy. 105
Start Panel 107
Bracket 19,21
Hose 62, 63
Adaptor 15
15
Adapter Assy. Plug Button 101
Drag Link Assy 74
Adaptor 77, 78
Drag Link Assy 74
Adoptor 79, 80
Lever Assy. 106
Rod Assy 106
Lever 58
Hydraulic Line Assy
77
Hydraulic Line Assy
79
Sending Unit 1
9
Shroud Assy. 102
Battery 102
Box 102
Battery Hold Down
102
Cable 102
Cable 102
Cable Cable 102
Wiring Harness 2,102
102
Wire 102
Wire 102
Wire Wire 102
Wire 102
Box 102
Battery Hold Down 102
Wiring Harness 102
Bracket 2
Special Cross 62, 63
Hose 62
Hose 62, 63
Hose 62, 63
Hose 21, 62
Light Mtg. Plate 102
Tail Lamp Assy 102
Side Panel Assy 9
Side Panel Assy 9
9
Hood Assy Hood Assy 9
Panel 9
Hose 19
Hose 21,22
Master Cyl. 98
Bracket 17,18
Stop 17,18
Cable 107
Spring 17,18
Wheel Disc & Rim Base 103
Tire 103
Tube 103
Flap 103
Knob 17,18
Sealed Beam Unit
102
Sealed Beam Unit
102
Tube 107
Head Lamp Assy 102
Back Up Lamp Assy
102
Bracket 102
Gauge 101'
Gauge 101
INS]
Page No.
Part No.
551321
551322
551323
551331
551336
551347
551348
551373
551384
551434
551479
551489
551494
551196
551497
551503
551510
551512
551515
551520
551521
551523
551528
551530
551539
551541
551542
551544
551605
551613
551644
551684
551685
551688
551689
551696
551711
551717
551742
551745
551746
551756
551759
551777
551834
551835
551837
551872
551873
551876
551896
551902
551906
551971
551991
551992
551996
552017
552039
552041
552149
552152
552156
552164
552165
552166
552167
552171
552172
552191
552264
552290
552296
MICHIGIM
Description Page No.
101
Gauge 101
Gauge Sender Unit 1, 62, 63
Filter 4,19,21
Hose 19
Washer
5
Washer
5
Bushing 12, 59, 60
95, 98, 106
Fuel Gauge 105
Bumper
9
Gasket
81
Washer 81
Bell Crank Assy 59, 60
Sleeve 59, 60
Bolt 59, 60
Dash Lamp 101
Light Mtg. Plate Assy 102
Rod Assy 18
Cam Assy. 12
Pointer Assy
12
12
Arm Assy Tube 12
Clamp 15
Switch
2
Bar
9
Lock Ring 103
SideRing 103
Cap
9
Nut 91, 92
Rod Assy 12
Spring
12
Adaptor , 103
Valve Cap 103
Cable & Conduit Assy... 96
Cable & Conduit Assy._. 96
Retainer 96
Bucket Assy
11
Bucket Assy
11
Lever 96
Cable & Conduit Assy... 96
Cable & Conduit Assy.“ 96
Gasket
15
Rod Assy 17
Support Assy
1
Clip 96
Washer
9
Bracket 96
Line Assy 62
Line Assy 62
Line Assy 62
Tee 62, 63
Clip 107
Gasket
82
Grease Gun 102
Boom Cylinder Assy 91
Boom Cylinder 91
Bracket 62, 63
Return Line
19
Rod 106
Tire 103
Clip 79
Bolt 75, 77, 79
Hose 63
Handle 102
Hammer 102
Pliers 102
Screwdriver 102
Tool Bag 102
Wrench 102
62
Line Assy Fitting
97
LineAssy 62, 63
62, 63
Hose -
MARK
EQUIPMENT
Part No.
Description
552298
552300
552302
552323
552336
552373
552374
552375
552377
552380
552381
552382
552383
552384
552385
552386
552387
552470
552473
552474
552483
552486
552487
552550
552602
552650
552696
552732
552814
552825
552826
552837
552838
552839
552842
552844
552845
552846
552847
552856
552863
552878
552880
552884
552885
552896
552935
552938
552941
552944
552946
552982
553139
553144
553145
553284
553324
553339
553340
553348
553349
553361
553412
553417
553419
553466
553664
553744
553858
553967
553982
553984
553985
553986
22
Line Assy 19
Line Assy Line Assy. 19,21
Spring 106
9
Hood Catch Assy
95
Master - Cylinder 97
Hose Floorboard Assy.
105
Clevis 95
102
Clip 102
Clip Brake Line 97
Brake Line 97
97
Brake Line 97
Brake Line 97
Brake Line Brake Line 97
62, 63
Filter Bracket 62, 63
LineAssy 62, 63
Packing 91,92
Adaptor 91, 92
Adaptor 91,92
11
Pin 103
Lock Ring 103
Side Ring Wheel Disc & Rim Base..103
19,21
Clip 3
Glow Plugs 2
Stud 2
Fuel Line Assy 1
Screw 2
Clip 1
Washer 2
Clamp 2
Cable 2
Cable 2
Cable 2
Cable 2
Cable Kit Bucket Assy 11
12
Arm Assy PointerAssy 12
Spacer 3
2
Spacer 15
Hose 101
Wire 101
Wire Bracket 3
69
Booster. Assy. Wire 101
91, 92
Shim 3
Harness Wiring Harness 102
102
Wiring Harness Reservoir 83
Hose 62
Nipple 86, 87
Hose 86, 87
Starter Assy 3
Housing 3
Ignition. Switch 101
Wrench 102
85
Hydraulic Pump Hose 87
Cable 102
Clip 107
Support Assy 9
4,21
Filter 17
Cable Line Assy 21
Line Assy 21
Line Assy 21
Bracket 21
PM 1188
Page No.
Part No.
Description
553988
554016
554023
554071
554081
600183
600259
601212
602350
610097
610098
610386
611074
613750
616533
616775
616795
616796
616813
617337
617863
618319
619016
619018
619019
619023
619027
619029
619052
620235
620238
620558
621279
622026
622027
622028
622029
622030
623762
623829
626515
626516
626530
626561
627982
6305.06
639796
645432
647300
647310
648304
648382
650737
652772
655281
661555
661559
661560
661561
661562
661563
661564
Rod Assy 17
Cable 102
Tire 103
Tire 103
Bushing 90
102
Stud Push Button 101
Clamp 101
Separator 101
Nipple 2
Nipple 2
86, 87
Hose Fuse 101
Copper Gasket 97, 98
Hose 86, 87
Washer 9,105
Washer 106
Washer 12, 59, 60, 90
Washer 9, 72
Seal 31
Nut 72
83
Copper Washer Washer 96
Washer 17,22
Washer 1,102
Washer 25, 26
Washer 31
Washer 1
1
Fan Fitting 97
Copper Gasket 97, 98
Elbow 3,22
Bracket 105
65
Connector Assy. Screw 65
Cover 65
Screw 65
Washer 65
Pin 17,1 8
17,18
Pedal Pin 6
Silent Block 6
Clamp 101
Bushing 6
105
Gasket Baffle 1
HornButtonAssy
65
Hose 86, 87
Horn 105
Relay 105
Nut 65
Starter Assy 3
Pin 51
2
Cable Nipple 15
Fuse 101
Hose 75, 76, 77, 78
Hose 75, 77
Hose 79
Hose 79
Hose 76, 78, 79, 80
UnionAdaptor__75, 76, 77
78, 79, 80
Hose 79
Split Flange 87
Pin 69
Ring 69
Bushing 69
1
Generator Assy Ring 85
Nipple 76, 78, 80
Nipple 76, 78, 80
Hose 80
Hose 78
[ N6]
661568
663093
664131
664138
664769
664858
666542
666846
666858
672712
672806
Page No.
MICHIG1111
Part No.
Description
Page No.
691800
692722
692843
695811
695914
695930
712170
712175
712766
713133
713134
713997
800648
800653
800656
800657
800809
800810
800811
800815
815202
815203
815204
850085
850091
850311
850756
850813
851756
851762
851770
852135
853182
853187
853227
853357
853368
853372
853373
853376
853379
853380
853384
853385
853391
853394
853395
853402
853405
853408
853412
853433
853464
853586
853599
853749
853751
853753
853754
857243
857729
857741
857852
858150
858225
858226
85822 7
858232
858233
858234
858235
858236
858237
858238
Hose Bolt Pump Bolt Wheel Screw Hose Hose Hose Ring Washer Bearing Hub & Ring Assy
Control Valve Assy
Gear & Ring Assy
Cover & Valve Assy
Shaft & Hub Kit..25,
Shaft & Hub Kit Shaft & Hub Kit Trans. Case Assy
Gear & Pinion Set
Diff. Case Kit Gear & Pinion Set
Condenser Rotor Nut Nut Armature Gasket Bolt & Washer Assy
Lash Adjuster Drive Assy Cover Assy Shim Kit Main Jet Bushing TerminalAssy Adjuster Bearing Cover Cup Gasket Key Nut Seal Seat Spring Connector Link Repair Kit BallNut Guide Spring Clamp Housing Gasket Gasket Spring Retainer Seat Strap Bearing Assy Lkwshr Cap Felt Seal Spring Seat Housing Plate Spring Shield Cover BallStud Screw Garter 86, 87
97
21
61
65
65
63
15
76
82
81,82
27, 28
27
31
27
31
26, 27
25
26
27
57
57
57
2
2
1
65
3
65
65
65
3
65
65
2
65
65
65
65
65
65
65
65
65
65
65
65
94
94
65
65
84, 85
65
2
2
84
84
84
84
1
65
65
2
2
67, 69
67, 69
67, 69
67
67
67
67, 69
67, 69
67, 69
67
CU IRK
EQUIPMENT
CONSTRUCTION
Part No.
Description
Page No. I
Part No.
Description
858239
858240
858241
858242
858243
858244
858245
858246
858247
858249
858251
858252
858253
858254
858256
858257
858259
858260
858263
858264
858266
858267
858268
858270
858271
858272
858274
858278
858279
858280
858281
858282
858283
858284
858285
858286
858287
858288
858289
858290
858291
858293
858294
858295
858296
858298
858299
858302
862092
862257
863045
863051
863052
863053
864519
864525
864539
864548
864559
867580
868980
868981
868982
868984
868986
868988
868991
868992
868993
868994
868996
868997
868999
869000
Wiper Spacer Wiper Retainer Packing Packing Packing Bushing Cap Rod ,..
Piston Ring Piston Nut Spring Tube Cylinder Ring Cap Head Screw Guide Spring Guide Seat Ball Spring Washer Washer Spool Spring Washer Nut Ring Guide Spring Oil Seal Retainer Sleeve End Plate Stem Cover Body Plug Key Nut Pad Spring Plug Seal Flange Nut Screw Screw Gasket Switch Brush Armature Drive Assy Housing Ring Nut Spring Ball Stud Retainer Washer Valve Spool Washer Spring Ring Plug Piston Cap Nut Nut 67
67
67, 69
67
67, 69
67, 69
67, 69
67
67
67
67, 69
67
67
67
67
67
67
67
67
,67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67
67, 69
67
67
67
67
67
67
67
89
67
89
89
89
89
3
3
3
3
3
69
69
69
69
69
69
69
69
69
69
69
69
69
69
69
869001
869004
869005
869006
869007
869008
869010
869011
869012
869013
869014
869015
869016
869017
869018
869019
869020
869021
869449
870730
870732
870736
870739
870740
871535
871541
940000
940003
940005
940006
940008
940009
940010
940011
940013
940014
940015
940016
940017
940018
940022
940023
940024
940025
940026
940027
940028
940029
940030
940031
940032
940033
940034
940039
940040
940041
940045
940047
940048
940049
940050
940051
940052
940056
940057
940058
940059
940060
940061
940062
940063
940064
940068
940070
Shield Rod Cylinder Sub-Assy. Tube Spring Retainer Sleeve Retainer Washer Nut Key Seat Seat Spring Spacer Plug Key Repair Kit Screw Wiper Housing Rod Nut Armature Brush Bolt Gear Shaft Seal Nut Washer Cover Seal Ring Plug Gear Seal Ring Ball Seat Spring Forging Plug Seal Assy. Cap Spring Cap Point Set Cartridge Kit Screw Guide Spring Gasket Plunger Seat Cartridge Kit Cap Cap Gasket Seal SealRing Bearing Gear Spring Seal Ring Cover Bolt Seal Ring Bearing Gear Bearing SealRing Spacer Spring Plunger Plunger Eye Spring PM 1188 MICHIGAil
MACHINERY DIVISION.
[N7]
Page No. I
69
69
69
69
69
69
69
69
69
69
69
69
69
69
69
69
69
67
95
69
69
69
69
69
1
1
84, 85
84
84
84, 85
84
84
'4, 84,85
74
84
84, 85
74
74
74
74
89
89
89
89
2
4
89
89
89
89
89
89
4
89
89
89
81
81
81
81
81
81
81
81
81
81
81
81
89
89
89
89
89
89
Part No.
Description
940072
940073
940074
940075
940076
940078
940079
940080
940081
940082
940083
940085
940088
940089
940090
940091
940092
940093
940104
940105
940107
940109
940111
940112
940113
940114
940115
940119
940120
940122
940123
940125
940127
940128
940129
940130
940131
940132
940134
940136
940137
940139
940141
940145
940146
940147
940148
940150
940151
940152
940153
940154
940155
940156
940157
940158
940174
940175
940177
940178
940179
940183
940230
940249
940318
940323
940330
Spring 89
Cape 89
Washer ' 89
Poppet 89
61
Cork Washer 61
Lkwshr 67
Repair Kit 61
Retainer Felt Washer 61
61
Slip Yoke. Assy 61
Spider & Brg. Assy 61
Stub Yoke 61
Nut 61
Bolt 61
Retainer 61
Washer 61
Felt Washer 61
Slip Yoke Assy 2
Coil 2
Voltage Regulator Cartridge 4, 19, 21
65
Steering Gear Assy
65
Gear 65
Housing Assy 65
Jacket 65
Pitman Arm Assy 65
Contact Assy 65
Spacer
65
Nut 65
Shaft Assy 65
Shaft Assy Pitman Arm Assy 65
Pitman Arm Assy 65
67
Sub Assy Repair Kit 98
93
Repair Kit 74
Forging 74
Forging 1
Pulley Brush 1
Starter Assy 3
Brush 3
67
Screw 67
Nut 67
Bolt 67
Sleeve 67
Spring Puncturing Tool 107
107
Pump 73
Ring Spring 73
73
Cap 73
Ball Stud 73
Socket 73
Retainer 3
Washer 11
Cutting Edge Kit 11
Cutting Edge Kit '2e
Carburetor 2
Repair Kit Gasket Kit FuelFilter 61
Tube Assy 61
Cork Washer 1
Generator Assy 1
Hourmeter 41
Hub & Screw Kit 45, 53
2
Distributor 11
Cutting Edge Kit 98
Clevis & Nut Assy 103
Wheel Assy 103
Wheel Assy - 11
Cutting Edge Kit 940331
940334
940356
940375
940376
940383
.
Page No.
CLIIRK
EQUIPMENT
Description Part No.
940393
940396
940582
940584
940585
940586
940587
940588
940653
940654
940663
940664
940665
940666
940667
940668
940669
940670
940671
940713
940714
940813
940897
941325
941326
941329
941422
941449
941480
941481
941484
941520
941552
941555
941556
941557
941558
PM 1188
Page No.
19
Line Assy. Kit
Reservoir Kit
83
3
Filter Assy
84
Bearing 84
Bearing 84
Bearing 84
Bearing Armature
1
61
Washer 61
Retainer 69
Spring 69
, Spring Valve Body 69
69
Seat
69
Poppet
69
Shim 69
Spring 69
Plug Repair Kit 69
Pulley
1
Washer
1
Spider & Brg. Assy 61
Pump
3
103
LockRing Flange 103
103
"0" Ring Valve Stem 103
Clamp 86, 87
Wheel Disc & Rim Base..103
103
Side Ring Ball Joint 17,18
Voltage Regulator
2
Ball
85
Gasket 85
Cover 85
Gear 85
Retainer 85
Part No.
Description
941559
941560
941561
941562
941563
941564
941565
941566
941572
941591
941621
941640
941643
941644
941645
941646
941652
941653
941770
941771
941943
941944
941945
942356
942357
942364
942403
942404
942406
Body Gear Bea ring Bearing Bea ring Shaft Seal Spring Back Up Washer
Spider & Brg. Assy
Fuel Pump Assy Wheel Assy. Minor Repair Kit Minor Repair Kit Minor Repair Kit MajorRepairKit
MajorRepairKit MajorRepair Kit Hydraulic Pump Retainer Screw Pump Repair Kit Repair Kit Body Washer Body Minor Repair Kit Major Repair Kit Packing & Adaptor
Kit Packing Kit Packing & Adaptor
Kit Packing Kit Hose Kit Hose Kit Fuel Tank Mtg. Kit
942407
942408
942409
942416
942417
942424
[ N8 ]
Page No.
85
85
85
85
85
85
85
84, 85
61
2
103
81
84
85
84
85
81
82
81
81
3
3
3
84
85
81
82
82
91, 92
91, 92
91, 92
91, 92
15
15
105
minium
Part No.
Description
942427
942428
942431
942432
942478
942513
942514
942515
942516
942517
942518
942519
942520
942648
942649
942650
942651
942652
942658
942659
942670
952721
952779
952797
953103
953127
953129
953130
954601
956814
957212
957299
957361
957577
958166
958485
959302
Gear Set 84
Gear Set 81
Gear Set 85
Gear Set 82
Wheel Assy 103
Cover 82
Spring 82
Bearing 82
Bearing '82
Gear 82
Gear 82
Bearing 82
Spring 82
Shaft Seal 82
Seal Ring 82
Back Up Washer
82
SealRing 82
82
Plug Slip Yoke Assy. 61
61
Stub Yoke 82
Body Gasket 3
Washer 3
2
Gasket 3
Gasket 3
Injector 2
Gasket 1
Gasket 3
Injector 3
Gasket 93
Connector Link 4
Gasket Stud 3
Cartridge Kit 62, 63
4
FuelFilter 4,21
Cartridge Kit 69
Plug Page No.

MODEL 75A TRACTOR SHOVEL PARTS MANUAL

Transcription

Similar documents

Parts Manual for Onan B43M-GA016

1 - MinnPar

PARTS MANUAL MODEL 180 micHionn TRACTOR DOZER

967-0224 Onan DJA (spec A-V) Genset Parts manual