Service Manual

Transcription

Service Manual

DJ-G5
Service Manual
CONTENTS
+ SPECIFICATIONS
2
+ CIRCUIT DESCRIPTION
1) Receiver System
2) Transmitter System
3) PLL Synthesizer Circuit
4) CPU and Peripheral Circuit
5) Terminal function of CPU
6) Terminal function of 4094
7) Frequency Table
3~5
5
6
6~7
10~12
13
13
+ SEMICONDUCTOR DATA
+ PARTS LIST
RF Unit
IF Unit
CPU Unit
SVV UniL
UVCO Unit
VVCO Unit
CHARGE Unit
PTT Unit
Mechanical Parts
37~40
41~44
44~46
46
46
47
47
47
48
+ ADJUSTMENT
l) AK2341
14
2) BU4094BF
15
3) HD6433877
16
4) LC75366M
17
5) LC73881 M
18
6) M64076GP
19
7) MC3372VM
20
8) NJM21 00V
20
9) NJM2070M
21
10) RH5RH501A
22
11) RH5RH651A
22
12) S-80730SL-AT
23
13) S-AV28
24
14) S-AU57
24
15) S-81237SG-QE
25
16) TA75S01F
25
17) TA75W01FU
26
18) TC4W53F
26
19) TK10930VTL
27
20) uPD1 6430AGF-3B9
28
21) 24LC16B
29
22) Transistor, Diode and LED Outline Dra30
23) LCD Unit
31~32
1) Required Test Equipment
2) Adjustment for DJ-G5T/E
3) Adjustment Points
49
50
51
+ PC BOARD VIEW
1) RF Unit Side A
2) RF Unit Side B
3) IF Unit Side A
4) 1F Unit Side B
5) CPU Unit Side A
6) CPU Unit Side B
7) UVCO Unit
8) VVCO Unit
9) PTT Unit Side A
10) PTT Unit Side B
11) CHARGE Unit
12) SW Unit Side A
52
53
54
55
56
57
58
58
58
58
58
58
+ VOLTAGE TABLE
1) Diode
2) IC
3) Transistor
59~60
60~63
63~64
+ EXPLODED VIEW
1) Charge Unit
2) RF Unit
3) IF Unit/CPU Unit
4) Front/Rear View
33
34
35
36
+ BLOCK DIAGRAM
66~67
+ SCHEMATIC DIAGRAM
1) RF Unit
2) IF Unit
3) CPU Unit
4) UVCO Unit
5) VVCO Unit
6) CHARGE Unit
7) PTT Unit
68~69
70~71
72~73
74
75
76
76
ALINCO INCORPORATED
TWIN 21 M.I.D. TOWER BUILDING 23F, 1-61, 2-CHOME,
SHIROMI CHUO-KU , OSAKA, 540-8580 JAPAN
Tel (81)6-6946-8150 fax (81)6-6946-8175
e-mail: [email protected]
General
VHF
UHF
108.000~173.995 420.000~479.995
DJ-G5T L-band
(AM FM)
(FM)
1 30.000~l 73.995
Receiver range(MHz)
R-band
(FM)
DJ-G5E
144.000~145.995 430.000~439.995
Transmitter range(MDJ-G5T
144.000~147.995 438.000~449.995
DJ-G5E
144.000~145.995 430.000~439.995
F2E.,F3E(FM)
Modulation
50 ohm
Antenna impedance
-10 ~ +60*C
Operating temperature range
4.5~16.0(13.8)
Supply voltage (rated voltage) External (V)
4.5~16.0(4.8)
Ni-Cd(V)
Tx Hi: 13.8VDC(external)
approx. 1.4A
approx. 1.5A
Tx Hi: 9.6VDC(Ni-Cd)
approx. 1.4A
approx. 1.5A
approx. 1.4A
approx. 1.5A
approx. 1.0A
approx. 1.2A
Current
TxMid: 4.8VDC(Ni-Cd)
approx. 0.8A
(regulated supply voltage)
TxLo: 4.8VDC(Ni-Cd)
approx. 0.5A
Rxsquelched(twinband)
approx. 85mA
Rxsquelched(monoband)
approx. 50mA
approx. 25mA
Rx Battery-Save On (800/200 twin band)
Negative ground
Ground
2k ohm
Microphone impedance
W57(63) x H138(155) x D27.5(31.5)
Dimensions without projection (with projections)
approx. 350g
Weight (Ant. belt-clip, strap, and Ni-Cd EBP-33N inclusive)
Transmitter
Hi: 13.8VDC(external)
approx. 5W
Power output
Hi: 9.6VDC(Ni-Cd)
approx. 4.5W
(regulated supply voltage)
Hi: 7.2VDC(Ni-Cd)
approx. 3.5w
approx. 3W
Hi: 4.8VDC(Ni-Cd)
approx. l.5W
approx. 1 W
Modulation
Variable reactance
Maximum deviation
+/-5kHz
Spurious emission
notmorethan-60dB
Receiver
System
First l.F.
Second l.F.
Sensitivity
Double-conversion superheterodyne
38.9MHz
45.1 MHz
455kHz
L-band: 144.000~147.995MHz
R-band: 438.000~449.995MHz
L-band: 438.000~449.995MHz
DJ-G5T R-band: 144.000~147.995MHz
L-band: 144.000~145.995MHz
R-band: 430.000~439.995MHz
L-band: 430.000~439.995MHz
DJ-G5E R-band: 144.000~145.995MHz
Squelch sensitivity
Selectivity (-6dB/-60dB)
A.F.output(@10% distortion)
better than -16dBu better than -15dBu
better than -12dBu
better than -16dBu better than -15dBu
better than-12dBu
better than-20dBu (0.1uV)
more than 12kHz / less than 30kHz
100mW(8ohm load)
CIRCUIT DESCRIPTTON
1) Receiver System
The receiver system is the double-conversion superheterodyne. ln L band the first
IF is 38.9MHz and second IF is 455kHz, and in R band the first IF is 45.1MHz and
second IF is 455kHz.
1 Front End
1-1 108.00MHz~ 173.995MHz (144M Band Main)
The receiving signal is passed through the low-pass filter (L90, L91 , L92, C220,
C229, C230, C231, C235), and amplified in RF amplifier (Q77), then led to the
resonant circuit (L85, L86, varicap D68, D69). The signal is amplified in RF
amplifier Q75, and passed through the resonant circuit (L81 , L82 varicap D66 and
D67), then converted into the frequency of 38.9MHz in the mixer Q79.
Two resonant circuits consisting of L85, L86, varicap D68, D69, L81 , L82, varicap
D66, D67, are controlled by the trucking voltage to obtain the best condition to the
receiving frequency.
The local signal from VVCO OUT is passed through the buffer Q79, and fed to the
base of the mixer Q76. The sum of the displayed frequency and IF frequency is
employed.
1-2 420.00MHz~51 1.995MHz: (430M Band Sub)
The receiving signal is passed through the band-pass filter (C59, C60, C61 , C66,
C67, C68, L57, L58, L53, L54), RF amplifier (Q62, Q72), band switch (D63), and
high-pass filter (C175, C176, C186, C187, L77, L78), and converted into the
frequency of 38.9MHz in mixer (Q74).
The local signal is passed through the buffer (Q70), and the difference frequency
between IF frequency and the displayed frequency is fed to the base of the mixer
(Q74).
1-3 130.00MHz~173.995MHz (144M Band Sub)
The receiving signal is passed through the low-pass filter (L90, L91 , L92, C220,
C229, C230, C231 and C235), and RF amplifier (Q68), low-pass fitter (C145,
C146, C153 and C154), then converted into the frequency of 45.1MHz in the mixer
(Q67).
The local signal is passed through the buffer (Q69), then the sum of displayed
frequency and IF frequency is fed to the base of the mixer (Q67).
1-4 420.00MHz~51 1.995MHz (433M Band Main)
The receiving signal is passed through the band-pass filter (C59, C60, C61 , C66,
C67, C68, L57, L58, L53, L54), RF amplifier (Q62, Q72) and the band-pass filter
(FL51), and amplified in RF amplifier (Q63), then converted into the frequency of
45.1MHz.
The band-pass filter (FL51) is the helical filter to obtain the band width characteristics.
The local signal from UVCO OUT is passed through the diode switch (D58), buffer
(Q64), then the difference frequency between the displayed and IF is fed to the
base ofthe mixer (Q61).
2 IF
2-1 L Band
The sum/difference between the receiving signal and local signal is made in each
mixer. The crystal filter (XF53) selects the difference of 38.9MHz and
eliminates unwanted signal, then it is amplified in the first IF amplifier (Q78).
2-2 R Band
The sum/difference between the receiving signal and local signal is made in each
mixer. The crystal filter (XF51) selects the difference of 45.l MHz and
eliminates unwanted signal, then it is amplified in the first IF amplifier (Q60).
3
3 Demodulation
3-1 L Band
After amplified in the first IF amplifier (Q78), the signal is fed to the demodulation
IC (IC302) Pin24. The first IF signal outputted to Pin24 (38.9MHz) is mixed in the
mixer of IC302 with the local signal of 38.455MHz which is oscillated in the
oscillation circuit of IC302 and the crystal oscillator (X303), then converted into the
second IF signal of 455kHz. The second IF is supplied from the IC302 Pin3. After
eliminating unwanted signal by the ceramic filter (FL302), the signal is applied to
Pin5 and Pin7.
As for the FM demodulation, the second IF signal applied to Pin7 is demodulated
in limiter amplifier and quadrature detection circuit of IC302 when IC302 Pinl4 is
open, and it is outputted from Pinl2 as the audio signal.
As for the AM demodulation, the second IF signal applied to Pin5 is demodulated
in AM amplifier and AM detection circuits of IC302 when the voltage of IC302
Pin14 is low, and it is outputted from Pinl3 as the audio signal.
3-2 R Band
After amplified in the first IF amplifier (Q60), the signal is applied to the demodulation lC301, Pinl6. It is mixed in the mixer of IC301 with the local signal of
45.555MHz which is oscillated in the oscillation circuit and the crystal oscillator
(X301) of IC301, then converted into the second IF signal of 455kHz. The second
IF is outputted from IC301 Pin3, and applied to Pin5 and Pin7 after eliminating
unwanted signal by the ceramic filter (FL30l).
4 Audio Circuit
4-1 FM (L band The audio signal supplied from IC302 is pre-emphasized white transmitting. So
the audio frequency should be compensated in the de-emphasis circuit (R366,
C363), then the signal is passed through FM/AM selection switch (IC303). The
frequency of 300Hz or below is cut in the audio high-pass fitter circuit (Q313), and
it is applied to the electronic volume (IC304) Pin1. The signal is passed through
the buffer (IC306), and adjusted the volume, then led to the audio power amplifier
(IC307) to drive the speaker.
4-2 AM (L band When AM mode is selected, the switching transistor (Q312) is turned ON, and
IC302 Pin14 becomes low, then AM demodulation circuit of IC302 is activated.
The audio signal provided from IC302 Pin14 is passed through the de-emphasis
circuit (R362, C360), and FM/AM selection switch (IC303), then led to audio highpass filter circuit (Q313), electronic volume (IC304), buffer (IC306) and the audio
power amplifier (IC307) to drive the speaker.
Note:
The FM detection circuit in IC301 (TK10930) is operating even while AM receiving.
(The squelch circuit is activated by FM detection output.) So the FM audio is not
outputted by FM/AM selection switch (IC303).
4-3 FM (R band)
The audio signal supplied by IC301 Pin9 is compensated the audio frequency
characteristics in de-emphasis circuit (R330, C327), and the signal is passed
through the audio high-pass filter (Q306), then applied to the electronic volume
(IC304) Pin20. It is passed through the buffer (IC305), and led to the audio power
amplifier (IC307) to drive the speaker.
5 Squelch Circuit
5-1 L Band
A part of the audio signal of IC302 Pin12 is selected and amplified by the noise
amplifiers in R351 , R352, R350, R353, C351, C352, C353, and IC302. Then it is
supplied from IC302 Pin20 to be amplified again in the noise amplifier (Q309). The
amplified noise factor is rectified in D302, adjusted the level in VR303, and applied
to CPU (IC508) Pin96, then converted to the digital signal.
4
5-2 R Band
A part of the audio signal of IC301 Ping is selected and amplified by the noise
amplifiers in R316, R317, R318, R319, C318, C319, C320, and IC301. Then it is
supplied from IC301 Pin11 to be amplified again in the noise amplifier (Q303). The
amplified noise factor is rectified in D301 , adjusted the level in VR30l , and applied
to CPU (IC508) Pin97, then converted to the dligital signal.
6 Attenuator Circuit
6-1 VHF Band
When the ATT key is pressed, "L" is applied from shift resistor (IC52) Pin14, and
D71 is turned ON, then the Attenuator circuit (Q56, R151, C194, R160) is activated.
The receiving signal passed through the low-pass filter is attenuated approximately
15dB by the attenuator to decrease the interference of the adjacent channel, etc.
6-2 UHF Band
When the ATT key is pressed, "L" is applied from shift resistor (IC52) Pin13, and
D55 is turned ON, then the Attenuator circuit (Q56, R73, C90, R80) is activated.
The receiving signal passed through the low-pass filter is attenuated approximately
15dB by the attenuator to decrease the interference of the adjacent channel, etc.
2) Transmitter System
1 Demodulation Circuit
The voice is converted into the electric signal by the internal or external microphone, then it is applied to the mic amplifier (IC310). This IC310 has two operational amplifiers. The pre-emphasis and IDC consist of Pin1, 2 and 3, and the
splutter filter consists of Pin5, 6 and 7.
The output from the microphone amplifier is passed through variable resistors
VR305 and VR306 for maximum deviation adjustment to cathode of varicap diode
of the VCO, controlling the VCO frequency and so producing a frequency-modulation.
2 Power Amplifier
2-1
The transmitting signal oscillated in VVCO is amplified in pre-drive amplifier (Q81)
and drive amplifier (Q80), then fed to the power module (IC54). The transmitting
signal amplified in IC54 is supplied to the antenna after attenuated the harmonics
enough in the antenna switch (D72) and the Low-pass filter (L90, L91 , L92, C220,
C229, C230,C231 , C235).
2-2
The transmitting signal oscillated in UVCO is amplified in pre-drive amplifier (Q54)
and drive amplifier (Q53), then fed to the power module (IC51). The transmitting
signal amplified in IC51 is supplied to the antenna after attenuated the harmonies
enough in the antenna switch (D52), and the bandi)ass filter (L57, L58, L53, L54,
C59, C60, C61, C66, C67, C68).
3 APC Circuit
3-1 VHF Band A part of transmitting voltage from low-pass filter is detected by D74, and converted into the DC voltage. The converted detection voltage is differential amplified, and the output voltage controls the bias voltage of power module (IC54) Pin2
to fix the transmitting power.
3-2 UHF Band
A part of transmitting voltage from low-passS filter is detected by D56, and converted into the DC voltage. The converted detection voltage is differential amplified, and the output power controls the bias voltage of power module (IC51) Pin2
to fix the transmitting power.
5
3) PLL Synthesizer Circuit
1 PLL
The data is sent to the PLL IC (IC53) Pin2 and the clock is sent to Pin3 from CPU
(IC508), then the ratio of the division is decided each in L band and R band.
Each VCO oscillating signal is amplified in the buffer (Q73: L band, Q66: R band),
and the signal in L band is applied to Pin15, then the signal in R band is applied to
Pin6. The programmable divider of IC53 is determined by frequency data, and it
divides (1/N) input signal of IC53. Resulting signal will be 5kHz or 6.25kHz.
2 Reference frequency division
The reference frequency of 5kHz or 6.25kHz according to the channel step is
produced by dividing the reference oscillation 12.8MHz (X51) by 2560 or 2048, the
data from CPU (IC508). The channel steps of 5kHz, 10kHz, 15kHz, 20kHz,
25kHz, 30kHz and 50kHz use the reference frequency of 5kHz, and the channel
step of l2.5kHz uses the reference frequency of 6.25kHz.
3 Phase comparator
The reference frequency of IC53 is 5kHz or 6.25kHz.
The VCO output frequency divided by N is compared with 5kHz or 6.25kHz in the
phase comparator.
4 PLL Loop Filter Circuit
If the phase error should occur in PLL, the charge pump of IC53 Pin13 (L band)
and Pin8 (R band) outputs the pulse. The signal is converted into the DC voltage
in PLL loop filter, then inputted to the varicap of each VCO unit.
5 VVCO Circuit (VHF Band)
Q705 is turned ON, and the desired frequency is oscillated in the Colpitts osclllator
consisting of Q701. The frequency control voltage is apprled to the varicap (D702,
D703), and the osciflating frequency is changed, then amplified in VCO buffer
(Q703), and outputted from the VCO unit.
6 VVCO Circuit (UHF Band)
Q704 is turned ON, and the desired frequency is oscillated in the Colpitts oscillator
consisting of Q702. The frequency control voltage is applied to the varicap (D704,
D705), and the oscillating frequency is changed, then amplified in VCO buffer
7 UVCO Circuit (UHF Band)
8 UVCO Circuit (VHF Band)
4) CPU and Peripheral Circuit
1 LCD Display Circuit
The strobe, serial data, and clock are sent to the LCD driver (IC503) Pin 75~77
from CPU (IC508), and the LCD is activated with 1/4 duty and l/3 bias. The frame
frequency is 137Hz.
6
2 Display Lamp Circuit
The regulated power supply circuit consisting of Q505, Q507, R508, R509 supplies
H from CPU (IC508) when LAMP key is pressed. Then it is applied to the base
of Q507, and the voltage of 3.5V is outputted from the collector of Q505. lt is fed
to each LED (D503~D506, D509,D511 ,D513,D514).
3 Reset and Backup Circuit
When the voltage of approximately 3.0V or more is supplied from the external (DC
jack, battery), the reset signal of "H" level is outputted from Reset IC (IC506), and
it is fed to CPU (IC508) Ping, then the CPU is reset. Until the clock (X502) of CPU
is stabilized, the reset signal is fed to CPU after it is delayed in C522 and R58l.
When the voltage from external is decreased to approximately 3.3V or below, the
voltage of Pin18 in CPU is changed from "H" level to "L" level, then the CPU enters
into the backup mode.
4 S (signal) Meter Circuit
4-1 L Band
The DC voltage of IC302 Pin16 is low when the signal is weak and high when the
signal is strong. This change of DC voltage is adjusted the level at the trim pot
(VR304), and led to CPU (IC508) Pin98, then displayed on the LCD as S meter
after A/D converting.
4-2 R Band
The DC voltage of IC301 Pin13 is adjusted the level at the trim pot (VR302), and
led to CPU (IC508) Pin99, then displayed on the LCD as S meter after A/D
converting.
5 Full-duplex Circuit
When the DUP key is pressed, in the receiving side Q317 is turned ON and the
audio signal supplied to audio amplifier is decreased. ln transmitting side Q510 is
turned ON, and the modulation signaf is decreased to prevent the howling.
6 X-Band Repeater Circuit
ln X-band repeater mode, Q323 is turned OFF, the audio Signal which is opened
the squelch is passed through the audio high-pass filter (Q313: L band, Q306:R
band), and the signal is applied to the other modulation circuit. Then the radio
enters into the transmitting mode.
7 DTMF
7-1 Encoder
The DTMF encoder is built in the CPU (IC508). The DTMF signal output from
Pin91 is adjusted its level at VR308, and amplified by the mic amplifier (IC310),
then fed to the varicap for modulation of each VCO.
Simultaneously the monitor sound is passed through AF circuit, and it is supplied
from the speaker.
7-2 Decoder
A part of the audio signal which is demodulated in IC301 , IC302 is fed to the DTMF
switch (IC501), then only the selected band audio signal is fed to DTMF IC (IC502)
Pin1. The supplied signal is judged whether valid or not by the signal judgement
circuit in IC502, and converted into 4-bit code, then supplied to IC508 Pin85.
8 Tone Squelch
8-1 Encoder
The tone signal supplied from Tone IC (IC504) Pin21 (67.OHz~254.lHz) is adjusted the level at VR307, and amplified n the tone amplifier (Q322), then applied
to the varicap for modulation of each VCO.
8-2 Decoder
A part of the audio signal which is demodulated in IC301, IC302 is fed to the tone
switch (IC504), then only the selected band audio signal is fed to tone IC (IC504)
Pin1.
When the signal is accord with the programmed tone frequency, "LO" is outputted
from IC504 Pin14, and it is fed to CPU (IC508) Pin74, then the squelch is opened.
7
5) Terminal function of CPU
No. Name
Pin Name
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
ANO
AVSS
TEST
X2
X1
VSS
OSC1
OSC2
RES
NMl
P20
P21
P22
P23
P24
P25
P26
lRQO
P17
P16
P15
P14
P13
TMOFH
TMOFL
P10
VSS
V3
V2
V1
VCC
PA3
PA2
PA1
PA0
P50
P51
P52
P53
P54
P55
P56
P57
P60
P6l
P62
P63
P64
P65
P66
+BD
GND
GND
OPEN
VDD
GND
OSC1
OSC2
REST
VDD
CLK
DATA
STB1
STB2
STB3
OPEN
+BDSW
BU
RE1
RE2
PSW
OPEN
OPEN
BEEP
1750
XBR
GND
OPEN
OPEN
OPEN
VDD
LBSY
LCLK
LDATA
LSTB
PT5/PTT
MONt
TBST
FUNC
BP3
UHF
VOLU
SQLD
SQLU
SRCH
VHF
VOLD
KIN1
KIN2
KIN3
I/O
Description
H
I
/
/
Power supply voltage detection
Analog lN
L
HiZ
Analogground
Connect to ground
Open when not used
/
/
I
O
I
/
O
O
O
O
O
/
O
I
I
I
I
Power supply
O
O
O
/
Beep sound output
/
I
O
O
O
I
I
I
I
I
I
I
I
I
I
I
I
I
I
I
Power supply terminal
Ground
Internal oscillator input
Internal osciIIator output
CPU reset
At work
Clock input
Pulse
Pulse
Pulse
Pulse
Pulse
Normal
Normal
Normal
Normal
Normal
ON
Normal
OFF
OFF
OFF
OFF
Backup
ON
ON
ON
Pulse
Pulse
Normal
Pulse
Pulse
Repeater
Permitted
Normal
Normal
Inhibited
ON
OFF
OFF
OFF
Expanded
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
OFF
Inhibited
Pulse
Pulse
Permitted
OFF
ON
ON
ON
Normal
ON
ON
ON
ON
ON
ON
ON
ON
ON
ON
Data input
RF4094 strobe
lF4094 strobe
Electronic volume strobe
+BD input ON/OFF
Backup signal input
Rotary encoder up input
Rotary encoder down input
Power switch input
Tone burst output
Cross band repeater ON/OFF
Normal
Normal
Ground
LCD driver data input ON/OFF
LCD driver clock
LCD driver serial data
LCD driver strobe
PTT input
Monitor key input
TX(toneburst)input
Function key input
Band plan (TX/RX expansion)
UHF key input
VOL up key input
SQL down key input
SQL up key input
Search key input
VHF key input
VOL down key input
Key matrix input1
Key matrix input2
Key matrix input3
10
No.
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
Name
P67
P70
P71
P72
P73
P74
P75
P76
P77
P80
P81
P82
P83
P84
P85
P86
P87
P90
P91
P92
P93
P94
P95
P96
P97
VCC
PD0
PD1
PD2
PD3
PD4
PD5
PD6
PD7
PE0
PE1
PE2
PE3
AVCC
TONEM
TONED
VTref
AVref
AN7
AN6
AN5
AN4
AN3
AN2
AN1
Pin Name
KIN4
KOT1
KOT2
KOT3
KOT4
PRST
SDA
SCL
50SW
OPEN
TFD
UTBST
VTBST
VTXCV
UTXCV
VBSY
UBSY
LAMPC
PCNT
MUTE
RFD
DSW
TSW
TSQD
TSTB
VDD
AM
AFPC
VAFS
UAFS
OPEN
IFPC
VRXC
URXC
DSD
ACK
DSTD
DPD
AVCC
TRAC
DTON
VDD
AVCC
BP2
BP1
VSD
USD
VSMT
USMT
MRC
IIo
I
O
O
O
O
O
I/O
O
O
/
O
O
O
O
O
O
O
O
O
O
O
O
O
I
O
/
O
O
O
O
Description
O
O
O
I
O
I
O
/
O
O
/
/
I
I
I
I
I
I
I
IF power supply ON/OFF
Key matrix input4
Key matrix output1
Key matrix output2
Key matrix output3
Key matrix output4
PLL reset pulse input judgement
EEPROM data
EEPROM clock
5V ON/OFF
H
OFF
OFF
OFF
OFF
OFF
Normal
PL
PL
ON
Full duplex ON/OFF when transmittin Full duplex
Right side TX lamp ON/OFF
Left side TX lamp ON/OFF
ON
ON
VHF TX circuit for power supply
UHF TX circuit for power supply
VHF RX busy lamp ON/OFF
UHF RX busy lamp ON/OFF
ON
ON
Vcc ON/OFF
Muted
Microphone mute
Full duplex ON/OFF when receiving Full duplex
VHF
DTMF band selection
VHF
Tone band selection
None
Tone detection signal input
Pulse
Tone IC strobe
LAMP ON/OFF
L
ON
ON
ON
ON
ON
Pulse
SE
SE
OFF
Normal
OFF
OFF
ON
ON
ON
ON
OFF
OFF
Normal
Normal
UHF
UHF
Tone
Normal
HiZ
Normal
Normal
OFF
OFF
OFF
OFF
Power supply
AM
Audio amplifier power supply ON/OFFON
Muted
VHF AF mute
Muted
UHF AF mute
AM circuit ON/OFF
VHF IF circuit power supply
UHF IF circuit power supply
DTMF 4-bit data
DTMF clock
DTMF detection signal
DTMF operation ON/OFF
ON
OFF
OFF
Normal
Pulse
Signal
isstopped
FM
OFF
ON
ON
OFF
ON
ON
Pulse
Normal
None
Operation
A/D converter power supply
VHF trucking voltage output
Normal
DTMF signal output
Power supply for DTMF reference level
Power suppTy for A/D reference level
Band plan2
Band plan1 (destination)
VHF SD signal input
UHF SD signal input
VHF S meter signal input
UHF S meter signal input
Microphone remote control input
No signal
No slgnal
Analog in
Analog in
Analog in
Analog in
Analog in
11
6) Terminal function of 4094
VHF
145
MHz
VHF UHF UHF BS
433 433 145 OFF
MHz MHz MHz TIME
H
H
H
H
H/L
H/L
H/L
L
H
H
H
H
H/L
H/L
H/L
H
H
H
H
H
H/L
H/L
L
H/L
H
H
H
H
H/L
H/L
H
H/L
H
H
H
H
H
H
H
H
4094 po Port Name
Function
Logic
Description
Q11
Q12
Q13
Q14
Q15
Q16
Q17
Q18
UHl
UMlD
VHl
VMID
VATTC
UATTC
VCO4SW
VCO1SW
UHF high power control
UHF middle power control
VHF high power control
VHF middle power control
VHF RX attenuater control
UHF RX attenuater control
UHF VCO switch
VHF VCO switch
Active Low
Active Low
Active Low
Active Low
Active Low
Active Low
Active Low
Active Low
Low power
UHF middle=H
Low power
VHF middle=H
ATT ON
ATT ON
USUBC
UMAINC
UHF 145MHz power control Active Low
UHF 435MHz power control Active Low
H/L
H/L
H/L
H/L
H
L
L
H
H
H
VSUBC
VMAlNC
UPLLC
VPLLC
VHF 435MHz power control Active Low
VHF 145MHz power control Active Low
UHF VCO power control
Active Low
VHF VCO power control
Active Low
H
L
H/L
L
L
H
H/L
L
H/L
H/L
L
H/L
H/L
H/L
L
H/L
H
H
H
H
Q21
Q22
Q23
Q24
Q25
Q26
Q27
Q28
7) Frequency Table
Band IF Frequency Display frequency
VHF
38.9MHz
108.000~173.995MHz
420.000~511.995MHz
UHF
45.lMHz
130.000~173.995MHz
420.000~511.995MHz
UP/LOW
UP
Low
UP
Low
Oscillation frequency
146.900~212.895MHz
381.100~473.095MHz
175.100~219.095MHz
374.900~466.895MHz
Mode
FM/AM
FM/AM
FM
FM
13
(XA0505)
C58
C59
C60
C61
C62
C63
C64
C66
C67
C68
C69
C70
C71
C72
C73
C74
C75
C76
C81
C83
C84
C85
C86
C87
C88
C89
C90
C91
C92
C93
C95
C96
C97
C99
C101
C102
C103
C104
C105
C106
C107
C108
C109
C111
C112
C113
C115
C116
37
CU3031
CU3007
CU3006
CU3012
CU3011
CU3005
CU3010
CU3006
CU3010
CU3004
CU3031
CS0208
CU3002
CU3008
CU3002
CS0049
CU3031
CU3031
CU3031
CU3001
CU3002
CU3031
CU3047
CU3031
CU3001
CU3002
CU3031
CU3031
CU3031
CS0049
CU3031
CU3031
CU3031
CU3007
CU3009
CU3031
CU3003
CU3031
CU3031
CU3012
CU3011
CU3047
CU3007
CU3031
CU3006
CU3001
CU3007
CU3047
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
PARTS L1ST
RF Unit
Ref N Parts No. Description
RF Unit
C51 CU3031 Chip C.
C52 CE0373 Electrolytic C.
C53 CU3031 Chip C.
C56 CU3031 Chip C.
C57 CS0210 Chip Tantal
C1608JB1H471KTA
C1608CH1H060CTA
C1608CH1H050CTA
C1608CH1H120JTA
C1608CH1H100CTA
C1608CH1H040CTA
C1608CH1H090CTA
C1608CH1H050CTA
C1608CH1H090CTA
C1608CH1H030CTA
C1608JB1H471KTA
TMCMA0J475MTR
C1608CH1H010CTA
C1608CH1H070CTA
C1608CH1H010CTA
TMCSA1C105MTR
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608CH1H0R5CTA
C1608CH1H010CTA
C1608JB1H471KTA
C1608JB1H103KTA
C1608JB1H471KTA
C1608CH1H0R5CTA
C1608CH1H010CTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H471KTA
TMCSA1C105MTR
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608CH1H060CTA
C1608CH1H080CTA
C1608JB1H471KTA
C1608CH1H020CTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608CH1H120JTA
C1608CH1H100CTA
C1608JB1H103KTA
C1608CH1H060CTA
C1608JB1H471KTA
C1608CH1H050CTA
C1608CH1H0R5CTA
C1608CH1H060CTA
C1608JB1H103KTA
C1608JB1H471KTA
16MV100UW
C1608JB1H471KTA
C1608JB1H471KTA
TMCMB0J156MTR
RF unit
Parts Name
Ver. Ref No Parts No.
C117 CS0376
C120 CU3031
C121 CS0213
C122 CS0213
C123 CU3051
C125 CU3002
C126 CU3003
C127 CU3003
C129 CS0063
C130 CU3019
C131 CU3031
C132 CU3031
C133 CS0377
C138 CU3035
C139 CU3031
C140 CU3003
C141 CU3035
C142 CU3035
C143 CU3047
C144 CS0049
C145 CU3013
C146 CU3013
C147 CU3035
C149 CU3023
C150 CU3031
C152 CU3011
C153 CU3019
C154 CU3013
C156 CU3019
C158 CU3021
C159 CS0213
C160 CS0213
C161 CU3051
C163 CU3002
C165 CU3035
C166 CU3018
C167 CU3017
C168 CS0063
C169 CU3031
C170 CU3031
C171 CU3031
C173 CU3031
C174 CU3035
C175 CU3006
C176 CU3004
C178 CU3031
C179 CU3035
C180 CS0377
C183 CU3004
C184 CU3003
C185 CU3031
C186 CU3006
C187 CU3006
C188 CU3019
C189 CU3035
C190 CU3003
Description
Chip Tantal
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
RF unit
Parts Name
TMCMA0G226MTR
C1608JB1H471KTA
TMCMA1A225MTR
TMCMA1A225MTR
C1608JB1E223KTA
C1608CH1H010CTA
C1608CH1H020CTA
C1608CH1H020CTA
TMCSA1V104MTR
C1608CH1H470JTA
C1608JB1H471KTA
C1608JB1H471KTA
TMCMB0G476MTR
C1608JB1H102KTA
C1608JB1H471KTA
C1608CH1H020CTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H103KTA
TMCSA1C105MTR
C1608CH1H150JTA
C1608CH1H150JTA
C1608JB1H102KTA
C1608CH1H101JTA
C1608JB1H471KTA
C1608CH1H100CTA
C1608CH1H470JTA
C1608CH1H150JTA
C1608CH1H470JTA
C1608CH1H680JTA
TMCMA1A225MTR
TMCMA1A225MTR
C1608JB1E223KTA
C1608CH1H010CTA
C1608JB1H102KTA
C1608CH1H390JTA
C1608CH1H330JTA
TMCSA1V104MTR
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H102KTA
C1608CH1H050CTA
C1608CH1H030CTA
C1608JB1H471KTA
C1608JB1H102KTA
TMCMB0G476MTR
C1608CH1H030CTA
C1608CH1H020CTA
C1608JB1H471KTA
C1608CH1H050CTA
C1608CH1H050CTA
C1608CH1H470JTA
C1608JB1H102KTA
C1608CH1H020CTA
Ver.
C198
C199
C201
C202
C203
C204
C205
C206
C207
C208
C209
C210
C211
C212
C213
C214
C215
C216
C217
C218
C219
C220
C221
C222
C223
C224
C225
C226
C227
C228
C229
C230
C231
C232
C233
C234
C235
C236
C237
C238
C239
C240
C241
C242
C243
C244
C245
C246
CU3017
CU3016
CU3011
CU3035
CU3020
CU3013
CU3035
CS0366
CU3047
CU3022
CU3022
CU3019
CU3003
CU3035
CU3011
CU3017
CU3024
CU3024
CU3035
CU3035
CU3035
CU3007
CU3005
CU3015
CU3035
CU3035
CU3020
CU3015
CU3004
CU3011
CU3016
CU3018
CU3018
CU3035
CU3035
CS0049
CU3007
CU3002
CU3035
CU3035
CU3035
CS0210
CU3005
CU3002
CU3035
CU3035
CS0049
CU3035
Ref No Parts No.
C192 CU3035
C193 CU3001
C194 CU3035
C195 CU3035
C196 CU3001
C197 CU3014
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Description
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
C1608CH1H330JTA
C1608CH1H270JTA
C1608CH1H100CTA
C1608JB1H102KTA
C1608CH1H560JTA
C1608CH1H150JTA
C1608JB1H102KTA
TMCMA0G106MTR
C1608JB1H103KTA
C1608CH1H820JTA
C1608CH1H820JTA
C1608CH1H470JTA
C1608CH1H020CTA
C1608JB1H102KTA
C1608CH1H100CTA
C1608CH1H330JTA
C1608CH1H121JTA
C1608CH1H121JTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608CH1H060CTA
C1608CH1H040CTA
C1608CH1H220JTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608CH1H560JTA
C1608CH1H220JTA
C1608CH1H030CTA
C1608CH1H100CTA
C1608CH1H270JTA
C1608CH1H390JTA
C1608CH1H390JTA
C1608JB1H102KTA
C1608JB1H102KTA
TMCSA1C105MTR
C1608CH1H060CTA
C1608CH1H010CTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H102KTA
TMCMB0J156MTR
C1608CH1H040CTA
C1608CH1H010CTA
C1608JB1H102KTA
C1608JB1H102KTA
TMCSA1C105MTR
C1608JB1H102KTA
RF unit
Parts Name
C1608JB1H102KTA
C1608CH1H0R5CTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608CH1H0R5CTA
C1608CH1H180JTA
Ver.
Diode
1SS356TW11
Diode
1SS356TW11
HelicaI FilterQA0083
HelicaI FilterQA0099
IC
S-AU57
IC
BU4094BFT1
IC
M64076GP
IC
S-AV28
Chip L.
NL252018T1R0J
Chip L.
LL1608-F27NK
Coil
MR1.5 3.5T 0.4
Coil
MR1.5 4.5T 0.4
Coil
MR1.5 4.5T 0.4
Chip L.
LL1608-F27NK
Coil
MR1.5 3.5T 0.4
Coil
MR1.5 3.5T 0.4
Coil
MR1.5 4.5T 0.4
Chip L.
LL1608-F18NK
Chip L.
NL252018T1R0J
Chip L.
LL1608-F33NK
Chip L.
LL1608-F22NK
Chip L.
LL1608-F22NK
Chip L.
MLF1608DR10KTA00
Chip L.
LL1608-F33NK
Chip L.
LL1608-F22NK
Chip L.
LQN1A33NJ04
XD0272
XD0272
QA0083
QA0099
XA0382
XA0246
XA0352
XA0381
QC0288
QC0423
QKA35A
QKA45A
QKA45A
QC0423
QKA35A
QKA35A
QKA45A
QC0421
QC0288
QC0424
QC0422
QC0422
QC0430
QC0424
QC0422
QC0395
D76
D77
FL51
FL51
IC51
IC52
IC53
IC54
L51
L52
L53
L54
L55
L56
L57
L58
L59
L60
L61
L62
L63
L64
L65
L66
L67
L68
RF unit
Parts Name
TMCSA1C105MTR
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H471KTA
C1608JB1H102KTA
TMCMA0G106MTR
MA741WATX
RLS135TE11
MA741WATX
RLS135TE11
MA741WATX
DAN235UT106
1SS356TW11
DAN235UT106
1SS356TW11
DAN235UT106
1SS356TW11
DAN235UT106
DAN235UT106
1SS356TW11
1SV217TPH4
1SV217TPH4
1SV217TPH4
1SV217TPH4
1SS356TW11
RLS135TE11
RLS135TE11
MA741WATX
1SS356TW11
Description
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Ref N Parts No.
C247 CS0049
C248 CU3035
C249 CU3035
C250 CU3031
C251 CU3035
C252 CS0366
D51 XD0251
D52 XD0066
D53 XD0251
D55 XD0066
D56 XD0251
D57 XD0246
D58 XD0272
D59 XD0246
D60 XD0272
D61 XD0246
D62 XD0272
D63 XD0246
D64 XD0246
D65 XD0272
D66 XD0233
D67 XD0233
D68 XD0233
D69 XD0233
D70 XD0272
D71 XD0066
D72 XD0066
D74 XD0251
D75 XD0272
38
E
T
Ver.
Ref N Parts No.
L70 QKA25A
L72 QC0426
L73 QC0395
L74 QC0395
L75 QC0422
L77 QC0395
L78 QC0395
L79 QC0292
L81 QA0071
L82 QA0071
L83 QC0430
L85 QA0071
L86 QA0071
L87 QC0292
L88 QKA75A
L89 QC0427
L90 QKA75A
L91 QKA75A
L92 QKA75A
L94 QC0426
L95 QC0430
L97 QC0430
Q51 XT0088
Q52 XU0172
Q53 XT0119
Q54 XT0138
Q55 XU0063
Q56 XU0171
Q58 XU0171
Q59 XU0172
Q60 XT0108
Q61 XT0138
Q62 XT0138
Q63 XT0138
Q64 XT0138
Q65 XT0135
Q66 XT0138
Q67 XT0138
Q68 XT0138
Q69 XT0138
Q70 XT0138
Q72 XT0138
Q73 XT0138
Q74 XT0138
Q75 XT0138
Q76 XT0138
Q77 XT0138
Q78 XT0108
Q79 XT0138
Q80 XT0119
Q81 XT0138
Q82 XT0088
Q83 XU0172
Q84 XU0172
Description
Coil
Chip L.
Chip L.
Chip L.
Chip L.
Chip L.
Chip L.
Chip L.
Coil
Coil
Chip L.
Coil
Coil
Chip L.
Coil
Chip L.
Coil
Coil
Coil
Chip L.
Chip L.
Chip L.
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
RF unit
Parts Name
MR1.5 2.5T 0.4
LL1608-F47NK
LQN1A33NJ04
LQN1A33NJ04
LL1608-F22NK
LQN1A33NJ04
LQN1A33NJ04
NL252018T-2R2J
LQA0071-T
LQA0071-T
MLF1608DR10KTA00
LQA0071-T
LQA0071-T
NL252018T-2R2J
QKA75A
LL1608-F56NK.
QKA75A
QKA75A
QKA75A
LL1608-F47NK
MLF1608DR10KTA00
MLF1608DR10KTA00
2SA1213YTE12L
XP1501-TX
2SC3356-T1BR24
2SC5066-0(TE85L)
UN9211TX
XP1111-TX
XP1111-TX
XP1501-TX
2SC4649-TL
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SD2216R-TX
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC5066-0(TE85L)
2SC4649-TL
2SC5066-0(TE85L)
2SC3356-T1BR24
2SC5066-0(TE85L)
2SA1213YTE12L
XP1501-TX
XP1501-TX
Q85 XU0063
Q86 XU0063
R51 RK3026
R52 RK3026
R53 RK3026
R54 RK3051
R55 RK3074
R57 RK3050
R58 RK3050
R59 RK3040
R60 RK3056
R62 RK3050
R63 RK3049
R64 RK3034
R65 RK3049
R66 RK3066
R67 RK3050
R68 RK3038
R69 RK3026
R70 RK3026
R71 RK3026
R72 RK3046
R73 RK3061
R74 RK3058
R75 RK3050
R76 RK3026
R77 RK3034
R78 RK3040
R79 RK3043
R80 RK3026
R81 RK3058
R82 RK3026
R83 RK3026
R84 RK3026
R85 RK3058
R86 RK3033
R87 RK3058
R88 RK3035
R89 RK3020
R90 RK3061
R91 RK3060
R92 RK3062
R93 RK3026
R94 RK3050
R95 RK3042
R96 RK3050
R97 RK3050
R98 RK3064
R99 RK3036
R100 RK3047
R101 RK3062
R102 RK3050
R103 RK3053
R104 RK3050
Description
Transistor
Transistor
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
RF unit
Parts Name
UN9211TX
UN9211TX
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ123V
ERJ3GSYJ105V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ152V
ERJ3GSYJ333V
ERJ3GSYJ103V
ERJ3GSYJ822V
ERJ3GSYJ471V
ERJ3GSYJ822V
ERJ3GSYJ224V
ERJ3GSYJ103V
ERJ3GSYJ102V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ472V
ERJ3GSYJ823V
ERJ3GSYJ473V
ERJ3GSYJ103V
ERJ3GSYJ101V
ERJ3GSYJ471V
ERJ3GSYJ152V
ERJ3GSYJ272V
ERJ3GSYJ101V
ERJ3GSYJ473V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ473V
ERJ3GSYJ391V
ERJ3GSYJ473V
ERJ3GSYJ561V
ERJ3GSYJ330V
ERJ3GSYJ823V
ERJ3GSYJ683V
ERJ3GSYJ104V
ERJ3GSYJ101V
ERJ3GSYJ103V
ERJ3GSYJ222V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ154V
ERJ3GSYJ681V
ERJ3GSYJ562V
ERJ3GSYJ104V
ERJ3GSYJ103V
ERJ3GSYJ183V
ERJ3GSYJ103V
39
Ver.
Ref No Parts No.
R105 RK3050
R106 RK3026
R107 RK3034
R108 RK3026
R109 RK3050
R110 RK3061
R111 RK3026
R112 RK3022
R113 RK3022
R114 RK3026
R115 RK3026
R116 RK3034
R117 RK3042
R118 RK3061
R119 RK3061
R120 RK3030
R121 RK3036
R122 RK3066
R123 RK3050
R124 RK3050
R125 RK3050
R126 RK3050
R127 RK3053
R128 RK3047
R129 RK3057
R130 RK3026
R131 RK3026
R132 RK3026
R133 RK3026
R135 RK3026
R136 RK3036
R137 RK3050
R138 RK3035
R139 RK3036
R140 RK3061
R141 RK3060
R143 RK3024
R146 RK3062
R147 RK3034
R148 RK3061
R149 RK3022
R150 RK3022
R151 RK3026
R152 RK3042
R153 RK3042
R154 RK3026
R155 RK3026
R156 RK3001
R157 RK3033
R158 RK3058
R159 RK3034
R160 RK3053
R161 RK3061
R162 RK3018
Description
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
RF unit
Parts Name
ERJ3GSYJ103V
ERJ3GSYJ101V
ERJ3GSYJ471V
ERJ3GSYJ101V
ERJ3GSYJ103V
ERJ3GSYJ823V
ERJ3GSYJ101V
ERJ3GSYJ470V
ERJ3GSYJ470V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ471V
ERJ3GSYJ222V
ERJ3GSYJ823V
ERJ3GSYJ823V
ERJ3GSYJ221V
ERJ3GSYJ681V
ERJ3GSYJ224V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ183V
ERJ3GSYJ562V
ERJ3GSYJ393V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ681V
ERJ3GSYJ103V
ERJ3GSYJ561V
ERJ3GSYJ681V
ERJ3GSYJ823V
ERJ3GSYJ683V
ERJ3GSYJ680V
ERJ3GSYJ104V
ERJ3GSYJ471V
ERJ3GSYJ823V
ERJ3GSYJ470V
ERJ3GSYJ470V
ERJ3GSYJ101V
ERJ3GSYJ222V
ERJ3GSYJ222V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSY0R00V
ERJ3GSYJ391V
ERJ3GSYJ473V
ERJ3GSYJ471V
ERJ3GSYJ183V
ERJ3GSYJ823V
ERJ3GSYJ220V
Ver.
R163 RK3060
Chip R.
R164 RK3026
Chip R.
R166 RK3065
Chip R.
R167 RK3042
Chip R.
R168 RK3030
Chip R.
R169 RK3036
Chip R.
R170 RK3065
Chip R.
R171 RK3026
Chip R.
R172 RK3062
Chip R.
R173 RK3062
Chip R.
R174 RK3062
Chip R.
R175 RK3062
Chip R.
R176 RK3050
Chip R.
R177 RK3026
Chip R.
R178 RK3026
Chip R.
R179 RK3026
Chip R.
R181 RK3040
Chip R.
R182 RK3062
Chip R.
R184 RK3026
Chip R.
R185 RK3038
Chip R.
R186 RK3026
Chip R.
R187 RK3026
Chip R.
R188 RK3058
Chip R.
R189 RK3046
Chip R.
R190 RK3050
Chip R.
R191 RK3051
Chip R.
R192 RK3050
Chip R.
R193 RK3058
Chip R.
R194 RK3034
Chip R.
R195 RK3043
Chip R.
R196 RK3049
Chip R.
R197 RK3034
Chip R.
R198 RK3049
Chip R.
R199 RK3026
Chip R.
R200 RK3032
Chip R.
R201 RK3030
Chip R.
R202 RK3034
Chip R.
R203 RK3058
Chip R.
R204 RK3019
Chip R.
VC51 CT0012
Trimmer
VR51 RH0140
Trim.pot
VR52 RH0146
Trim.pot
VR53 RH0140
Trim.pot
VR54 RH0144
Trim.pot
W51 MYCKH4GGWire
X51 XQ0060
Crystal
XF51 XF0019
Filter
XF53 XF0020
Filter
TN0004
TS0101
TZ0049
RD0108
Resistor
RF unit
Parts Name
ERJ3GSYJ683V
ERJ3GSYJ101V
ERJ3GSYJ184V
ERJ3GSYJ222V
ERJ3GSYJ221V
ERJ3GSYJ681V
ERJ3GSYJ184V
ERJ3GSYJ101V
ERJ3GSYJ104V
ERJ3GSYJ104V
ERJ3GSYJ104V
ERJ3GSYJ104V
ERJ3GSYJ103V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ152V
ERJ3GSYJ104V
ERJ3GSYJ101V
ERJ3GSYJ102V
ERJ3GSYJ101V
ERJ3GSYJ101V
ERJ3GSYJ473V
ERJ3GSYJ472V
ERJ3GSYJ103V
ERJ3GSYJ123V
ERJ3GSYJ103V
ERJ3GSYJ473V
ERJ3GSYJ471V
ERJ3GSYJ272V
ERJ3GSYJ822V
ERJ3GSYJ471V
ERJ3GSYJ822V
ERJ3GSYJ101V
ERJ3GSYJ331V
ERJ3GSYJ221V
ERJ3GSYJ471V
ERJ3GSYJ473V
ERJ3GSYJ270V
CTZ10AW
MVR22HXBRN472
MVR22HXBRN473
MVR22HXBRN472
MVR22HXBRN223
#28YH1-045-H1
UM-1/T12.8MHZ
45.1MHz45M15BE
38.9MHz38M15B
Coil shield
Module earth DJG5
Silicon dumper UM1
JPW01R-01
40
Ver.
C327
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C341
C342
C343
C344
C345
C346
C347
C348
C349
C350
C351
C352
C353
CS0063
CU3047
CU3047
CU3047
CU8042
CU3047
CU3035
CS0366
CU3047
CS0366
CU3047
CU3047
CU3047
CS0376
CU3007
CU3012
CU3059
CU3059
CU3059
CU3059
CU3021
CU3053
CU3051
CU3047
CU3035
CU3023
CU3023
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
TMCSA1V104MTR
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
C2012JB1C104KTA
C1608JB1H103KTA
C1608JB1H102KTA
TMCMA0G106MTR
C1608JB1H103KTA
TMCMA0G106MTR
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
TMCMA0G226MTR
C1608CH1H060CTA
C1608CH1H120JTA
C1608JF1E104ZTA
C1608JF1E104ZTA
C1608JF1E104ZTA
C1608JF1E104ZTA
C1608CH1H680JTA
C1608JF1E333ZTA
C1608JB1E223KTA
C1608JB1H103KTA
C1608JB1H102KTA
C1608CH1H101JTA
C1608CH1H101JTA
IF unit
Ref N Parts No. Description Parts Name
IF Unit
C301 CU3047 Chip C.
C1608JB1H103KTA
C302 CE0374 Electrolytic C.16CV100BS
C303 CU3035 Chip C.
C1608JB1H102KTA
C304 CU3059 Chip C.
C1608JF1E104ZTA
C305 CS0378 Chip Tantal TMCMC0G107MTR
C306 CU3035 Chip C.
C1608JB1H102KTA
C307 CU3047 Chip C.
C1608JB1H103KTA
C308 CU3047 Chip C.
C1608JB1H103KTA
C309 CU3047 Chip C.
C1608JB1H103KTA
C310 CS0376 Chip Tantal TMCMA0G226MTR
C311 CU3006 Chip C.
C1608CH1H050CTA
C312 CU3008 Chip C.
C1608CH1H070CTA
C313 CU3059 Chip C.
C1608JF1E104ZTA
C314 CU3059 Chip C.
C1608JF1E104ZTA
C315 CU3021 Chip C.
C1608CH1H680JTA
C316 CU3051 Chip C.
C1608JB1E223KTA
C317 CU3047 Chip C.
C1608JB1H103KTA
C318 CU3035 Chip C.
C1608JB1H102KTA
C319 CU3023 Chip C.
C1608CH1H101JTA
C320 CU3023 Chip C.
C1608CH1H101JTA
C321 CU3035 Chip C.
C1608JB1H102KTA
C322 CU3059 Chip C.
C1608JF1E104ZTA
C323 CU8042 Chip C.
C2012JB1C104KTA
C324 CS0060 Chip Tantal TMCSA1E474MTR
C325 CU3047 Chip C.
C1608JB1H103KTA
C326 CU3035 Chip C.
C1608JB1H102KTA
C382
C383
C384
C385
C386
C387
C388
C389
C390
C391
C392
C393
C394
C395
C396
C397
C398
C399
C400
C401
C402
C403
C404
C405
C406
C407
C408
CU3035
CU3023
CU3023
CS0049
CS0049
CU3035
CS0049
CU3035
CU3059
CS0049
CU3035
CS0369
CU8042
CS0369
CU3035
CS0376
CU3047
CS0379
CU3047
CU3035
CU3047
CU3047
CU3047
CU3035
CU3047
CU3035
CU3035
C354 CU3035
C355 CU3059
C356 CU8042
C357 CS0060
C358 CU3047
C359 CS0366
C360 CU3051
C362 CU3035
C363 CS0063
C364 CU3047
C365 CU3047
C366 CU3047
C367 CU3047
C368 CU8042
C369 CU3047
C370 CU3051
C371 CS0376
C372 CS0376
C373 CU3047
C374 CS0216
C375 CS0377
C376 CS0376
C377 CS0049
C378 CS0376
C379 CS0376
C380 CS0049
C381 CS0376
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Description
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip Tantal
Chip Tantal
Chip Tantal
Chip Tantal
Chip Tantal
Chip Tantal
Chip Tantal
Chip Tantal
C1608JB1H102KTA
C1608CH1H101JTA
C1608CH1H101JTA
TMCSA1C105MTR
TMCSA1C105MTR
C1608JB1H102KTA
TMCSA1C105MTR
C1608JB1H102KTA
C1608JF1E104ZTA
TMCSA1C105MTR
C1608JB1H102KTA
TMCMD0J107MTR
C2012JB1C104KTA
TMCMD0J107MTR
C1608JB1H102KTA
TMCMA0G226MTR
C1608JB1H103KTA
TMCMC1A476MTR
C1608JB1H103KTA
C1608JB1H102KTA
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H102KTA
C1608JB1H103KTA
C1608JB1H102KTA
C1608JB1H102KTA
IF unit
Parts Name
C1608JB1H102KTA
C1608JF1E104ZTA
C2012JB1C104KTA
TMCSA1E474MTR
C1608JB1H103KTA
TMCMA0G106MTR
C1608JB1E223KTA
C1608JB1H102KTA
TMCSA1V104MTR
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
C2012JB1C104KTA
C1608JB1H103KTA
C1608JB1E223KTA
TMCMA0G226MTR
TMCMA0G226MTR
C1608JB1H103KTA
TMCMB1A106MTR
TMCMB0G476MTR
TMCMA0G226MTR
TMCSA1C105MTR
TMCMA0G226MTR
TMCMA0G226MTR
TMCSA1C105MTR
TMCMA0G226MTR
41
Ver.
Ref No Parts No.
C409 CS0366
C410 CU8042
C411 CU3051
C412 CU3035
C413 CU3027
C414 CU3039
C415 CU8042
C416 CU3021
C417 CS0063
C418 CU3047
C419 CS0366
C420 CU3035
C421 CS0049
C422 CU3059
C423 CU3051
C424 CU3051
C425 CU3051
C426 CU3051
C427 CU3047
C428 CU3031
C430 CU3031
C431 CU3035
C432 CU3031
C433 CU3031
C434 CU3035
C435 CU3031
C436 CU3035
C437 CU3035
C438 CU3047
C439 CU3035
C440 CU3023
C441 CU3023
C442 CU3035
C443 CU3051
C444 CS0366
C446 CS0049
CN301 UE0240
CN302 UP0282
D301 XD0250
D302 XD0250
D303 XD0290
D304 XD0291
D305 XL0036
D306 XD0290
D308 XD0291
D310 XD0239
FL301 XC0010
FL302 XC0010
IC301 XA0343
IC302 XA0223
IC303 XA0348
IC304 XA0345
IC305 XA0349
IC306 XA0349
IC307 XA0210
Description
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip Tantal
Connector
Connector
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Diode
Filter
Filter
IC
IC
IC
IC
IC
IC
IC
IF unit
Parts Name
TMCMA0G106MTR
C2012JB1C104KTA
C1608JB1E223KTA
C1608JB1H102KTA
C1608CH1H221JTA
C1608JB1H222KTA
C2012JB1C104KTA
C1608CH1H680JTA
TMCSA1V104MTR
C1608JB1H103KTA
TMCMA0G106MTR
C1608JB1H102KTA
TMCSA1C105MTR
C1608JF1E104ZTA
C1608JB1E223KTA
C1608JB1E223KTA
C1608JB1E223KTA
C1608JB1E223KTA
C1608JB1H103KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H102KTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608JB1H102KTA
C1608JB1H471KTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H103KTA
C1608JB1H102KTA
C1608CH1H101JTA
C1608CH1H101JTA
C1608JB1H102KTA
C1608JB1E223KTA
TMCMA0G106MTR
TMCSA1C105MTR
AXN440C530P
DJG5lF-RF Flex.
MA742TX
MA742TX
MA111-TX
MA729-TX
SML-310MTT86
MA111-TX
MA729-TX
MA142WATX
CFUM455F
CFUM455F
MC3372VM-EL
TK10930VTL
TC4W53FU(TE12)
LC75366M-TLM
TA75W01FU(TE12L)
TA75W01FU(TE12L)
NJM2070MT1
E/EX
Ver.
Ref N Parts No.
IC308 XA0341
IC309 XA0332
IC310 XA0342
IC311 XA0246
JK301UJ0022
JK302UJ0019
L301 QC0086
Q301 XT0088
Q302 XU0172
Q303 XT0135
Q304 XU0062
Q306 XT0135
Q307 XE0019
Q308 XU0062
Q309 XT0135
Q310 XU0062
Q312 XU0063
Q313 XT0135
Q315 XT0135
Q316 XU0062
Q317 XT0135
Q318 XT0088
Q319 XU0172
Q320 XU0063
Q321 XU0063
Q322 XT0135
Q323 XU0099
Q423 XU0062
Q326 XU0171
Q327 XU0062
Q328 XU0171
Q329 XU0171
R301 RK0114
R302 RK3058
R303 RK3040
R304 RK3055
R305 RK3042
R306 RK3055
R307 RK3047
R308 RK3038
R309 RK3026
R310 RK3050
R311 RK3041
R312 RK3058
R313 RK3042
R314 RK3062
R315 RK3038
R316 RK3066
R317 RK3046
R318 RK3038
R319 RK3050
R320 RK3050
R321 RK3056
R322 RK3042
R323 RK3038
Description
IC
IC
IC
IC
Jack
Jack
Coil
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
IF unit
Parts Name
RH5RH651A-T1
TA75S01F(TE85L)
NJM2100V-TE1
BU4094BFT1
HSJ1102-01-540
HSJ1493-01-010
NL322522T101J
2SA1213YTE12L
XP1501-TX
2SD2216R-TX
UN9111TX
2SD2216R-TX
2SJ144YTE85R
UN9111TX
2SD2216R-TX
UN9111TX
UN9211TX
2SD2216R-TX
2SD2216R-TX
UN9111TX
2SD2216R-TX
2SA1213YTE12L
XP1501-TX
UN9211TX
UN9211TX
2SD2216R-TX
UN9216-R-TX
UN9111TX
XP1111-TX
UN9111TX
XP1111-TX
XP1111-TX
ERJ6GEYJ010V
ERJ3GSYJ473V
ERJ3GSYJ152V
ERJ3GSYJ273V
ERJ3GSYJ222V
ERJ3GSYJ273V
ERJ3GSYJ562V
ERJ3GSYJ102V
ERJ3GSYJ101V
ERJ3GSYJ103V
ERJ3GSYJ182V
ERJ3GSYJ473V
ERJ3GSYJ222V
ERJ3GSYJ104V
ERJ3GSYJ102V
ERJ3GSYJ224V
ERJ3GSYJ472V
ERJ3GSYJ102V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ333V
ERJ3GSYJ222V
ERJ3GSYJ102V
42
E/EH
Ver.
Ref N Parts No.
R324 RK3040
R326 RK3061
R328 RK3050
R329 RK3042
R330 RK3046
R331 RK3046
R332 RK3067
R333 RK3051
R334 RK3066
R335 RK3042
R336 RK3060
R338 RK3050
R339 RK3038
R340 RK3062
R341 RK3074
R342 RK3042
R343 RK3038
R344 RK3026
R345 RK3050
R346 RK3042
R347 RK3045
R348 RK3072
R349 RK3038
R350 RK3066
R351 RK3046
R352 RK3038
R353 RK3050
R354 RK3050
R355 RK3056
R356 RK3042
R357 RK3038
R358 RK3040
R360 RK3061
R362 RK3049
R364 RK3067
R365 RK3042
R366 RK3046
R367 RK3050
R368 RK3046
R369 RK3067
R370 RK3051
R371 RK3066
R372 RK3042
R373 RK3060
R375 RK3062
R376 RK3038
R377 RK3062
R378 RK3066
R379 RK3066
R380 RK3058
R381 RK3058
R382 RK3074
R383 RK3074
R384 RK3074
Description
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
IF unit
Parts Name
ERJ3GSYJ152V
ERJ3GSYJ823V
ERJ3GSYJ103V
ERJ3GSYJ222V
ERJ3GSYJ472V
ERJ3GSYJ472V
ERJ3GSYJ274V
ERJ3GSYJ123V
ERJ3GSYJ224V
ERJ3GSYJ222V
ERJ3GSYJ683V
ERJ3GSYJ103V
ERJ3GSYJ102V
ERJ3GSYJ104V
ERJ3GSYJ105V
ERJ3GSYJ222V
ERJ3GSYJ102V
ERJ3GSYJ101V
ERJ3GSYJ103V
ERJ3GSYJ222V
ERJ3GSYJ392V
ERJ3GSYJ684V
ERJ3GSYJ102V
ERJ3GSYJ224V
ERJ3GSYJ472V
ERJ3GSYJ102V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ333V
ERJ3GSYJ222V
ERJ3GSYJ102V
ERJ3GSYJ152V
ERJ3GSYJ823V
ERJ3GSYJ822V
ERJ3GSYJ274V
ERJ3GSYJ222V
ERJ3GSYJ472V
ERJ3GSYJ103V
ERJ3GSYJ472V
ERJ3GSYJ274V
ERJ3GSYJ123V
ERJ3GSYJ224V
ERJ3GSYJ222V
ERJ3GSYJ683V
ERJ3GSYJ104V
ERJ3GSYJ102V
ERJ3GSYJ104V
ERJ3GSYJ224V
ERJ3GSYJ224V
ERJ3GSYJ473V
ERJ3GSYJ473V
ERJ3GSYJ105V
ERJ3GSYJ105V
ERJ3GSYJ105V
R385 RK3074
R386 RK3050
R387 RK3050
R388 RK3042
R389 RK3058
R390 RK3046
R391 RK3030
R392 RK0114
R393 RK3058
R394 RK3058
R395 RK3056
R396 RK3052
R397 RK3043
R398 RK3050
R399 RK3050
R400 RK3014
R401 RK3052
R402 RK3051
R403 RK1018
R404 RK3050
R405 RK3058
R406 RK3058
R407 RK3060
R408 RK3023
R409 RK3041
R410 RK3066
R411 RK3030
R412 RK3058
R413 RK3046
R414 RK3063
R415 RK3056
R416 RK3061
R417 RK3069
R418 RK3034
R419 RK3056
R420 RK3056
R421 RK3058
R422 RK3050
R423 RK3066
R424 RK3066
R425 RK3056
R426 RK3056
R427 RK3056
R428 RK3038
R429 RK3056
R430 RK3059
R431 RK3058
R433 RK3058
R434 RK3057
R435 RK3059
R437 RK3074
R438 RK3050
R439 RK3050
R440 RK3058
Description
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
IF unit
Parts Name
ERJ3GSYJ105V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ222V
ERJ3GSYJ473V
ERJ3GSYJ472V
ERJ3GSYJ221V
ERJ6GEYJ010V
ERJ3GSYJ473V
ERJ3GSYJ473V
ERJ3GSYJ333V
ERJ3GSYJ153V
ERJ3GSYJ272V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ100V
ERJ3GSYJ153V
ERJ3GSYJ123V
ERJ8GEYJ101V
ERJ3GSYJ103V
ERJ3GSYJ473V
ERJ3GSYJ473V
ERJ3GSYJ683V
ERJ3GSYJ560V
ERJ3GSYJ182V
ERJ3GSYJ224V
ERJ3GSYJ221V
ERJ3GSYJ473V
ERJ3GSYJ472V
ERJ3GSYJ124V
ERJ3GSYJ333V
ERJ3GSYJ823V
ERJ3GSYJ394V
ERJ3GSYJ471V
ERJ3GSYJ333V
ERJ3GSYJ333V
ERJ3GSYJ473V
ERJ3GSYJ103V
ERJ3GSYJ224V
ERJ3GSYJ224V
ERJ3GSYJ333V
ERJ3GSYJ333V
ERJ3GSYJ333V
ERJ3GSYJ102V
ERJ3GSYJ333V
ERJ3GSYJ563V
ERJ3GSYJ473V
ERJ3GSYJ473V
ERJ3GSYJ393V
ERJ3GSYJ563V
ERJ3GSYJ105V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ473V
43
Ver.
Ref No Parts No. Description
RE301 UR0012
Encoder
VR301 RH0142
Trim.pot
VR302 RH0148
Trim.pot
VR303 RH0142
Trim.pot
VR304 RH0148
Trim.pot
VR305 RH0142
Trim.pot
VR306 RH0142
Trim.pot
VR307 RH0146
Trim.pot
VR308 RH0146
Trim.pot
VR309 RH0146
Trim.pot
W301 MPCK06GGWire
W302 MACK02GGWire
X301 XQ0069
Crystal
X302 XK0002
Discriminator
X303 XQ0073
Crystal
X304 XK0002
Discriminator
TZ0049
FM0111
IF unit
Parts Name
EC09P20-89
MVR22HXBRN103
MVR22HXBRN104
MVR22HXBRN103
MVR22HXBRN104
MVR22HXBRN103
MVR22HXBRN103
MVR22HXBRN473
MVR22HXBRN473
MVR22HXBRN473
#28PH1-060-H1
#28AH1-020-H1
UM545.555MHZ
CDBM455C7
UM538.445MHZ
CDBM455C7
Silicon dumper UM1
IF earth DJG5
Ver.
C501 CU3047
C502 CU3047
C503 CU3047
C504 CU3035
C505 CU3035
C506 CU3047
C508 CU3023
C509 CU3047
C510 CU3047
C511 CS0208
C512 CU3035
C513 CS0208
C514 CU3101
C515 CS0049
C516 CU3035
C517 CU3023
C518 CU3019
C519 CU3047
C520 CU3018
C521 CU3085
C522 CS0064
C523 CU3014
C524 CU3014
C525 CU3085
C526 CU3018
C527 CU3035
C528 CS0380
C529 CU3047
C530 CU3035
C532 CU3051
C533 CS0049
C534 CS0060
C535 CU3035
C536 CS0381
C537 CS0378
C538 CU3059
C539 CU3035
C540 CU3031
C541 CU3035
CN50 UE0256
CN50 UE0241
D501 XL0028
D502 XL0028
D503 XL0045
D504 XL0045
D505 XL0045
D506 XL0045
D507 XD0290
D508 XD0291
D509 XL0036
D510 XD0238
D511 XL0036
D512 XD0238
Ref N Parts No.
Description
CPU Unit
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip Tantal
Chip Tantal
Chip C.
Chip C.
Chip C.
Chip C.
Connector
Connector
LED
LED
LED
LED
LED
LED
Diode
Diode
LED
Diode
LED
Diode
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H103KTA
C1608JB1H102KTA
C1608JB1H102KTA
C1608JB1H103KTA
C1608CH1H101JTA
C1608JB1H103KTA
C1608JB1H103KTA
TMCMA0J475MTR
C1608JB1H102KTA
TMCMA0J475MTR
C1608JB1C473KTA
TMCSA1C105MTR
C1608JB1H102KTA
C1608CH1H101JTA
C1608CH1H470JTA
C1608JB1H103KTA
C1608CH1H390JTA
C1608CH1H300JT-A
TMCSA1A155MTR
C1608CH1H180JTA
C1608CH1H180JTA
C1608CH1H300JT-A
C1608CH1H390JTA
C1608JB1H102KTA
TMCMD0G157MTR
C1608JB1H103KTA
C1608JB1H102KTA
C1608JB1E223KTA
TMCSA1C105MTR
TMCSA1E474MTR
C1608JB1H102KTA
TMCMB0J336MTR
TMCMC0G107MTR
C1608JF1E104ZTA
C1608JB1H102KTA
C1608JB1H471KTA
C1608JB1H102KTA
CFP0508-0201
AXN340C038P
BRPG1201W
BRPG1201W
PG1101F-TR
PG1101F-TR
PG1101F-TR
PG1101F-TR
MA111-TX
MA729-TX
SML-310MTT86
DA227TL
SML-310MTT86
DA227TL
CPU unit
Parts Name
44
Ver.
Ref N Parts No.
D513 XL0036
D514 XL0036
D515 XD0156
D516 XD0251
D517 XD0291
D518 XD0165
IC501 XA0348
IC502 XA0344
IC503 XA0355
IC504 XA0239
IC505 XA0348
IC506 XA0356
IC507 XA0358
IC508 XA0505
IC509 XA0219
IC510 XA0356
L501 QC0049
Q501 XU0171
Q502 XU0171
Q503 XU0063
Q504 XU0063
Q505 XT0140
Q506 XT0139
Q507 XT0135
Q508 XT0088
Q509 XU0172
Q510 XU0177
Q511 XU0047
Q512 XU0047
R501 RA0009
R502 RK3038
R503 RK3038
R504 RK3062
R505 RK3046
R506 RK3062
R507 RK3046
R508 RK3050
R509 RK3030
R510 RK3054
R511 RK3042
R512 RK3062
R513 RK3050
R514 RK3032
R515 RK3031
R516 RK3031
R517 RK3032
R518 RK3058
R519 RA0008
R520 RK3050
R521 RK3067
R522 RK3089
R523 RK3051
R524 RK3047
R525 RK3048
Description
LED
LED
Diode
Diode
Diode
Diode
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
Coil
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
CPU unit
Parts Name
SML-310MTT86
SML-310MTT86
DTZ3.6BTT11
MA741WATX
MA729-TX
DTZ5.1BTT11
TC4W53FU(TE12)
LC73881M-TLM
UPD16430AGF-3B9
AK2341
TC4W53FU(TE12)
S-80730SL-AT-T2
S-81237SG-QE-T2
HD6433877A35H
RH5RH501AT1
S-80730SL-AT-T2
NL322522T221J
XP1111-TX
XP1111-TX
UN9211TX
UN9211TX
2SB1181-TLQ
2SA1774TLR
2SD2216R-TX
2SA1213YTE12L
XP1501-TX
XP1216-TX
UMC3TR
UMC3TR
EXBV8V102JV
ERJ3GSYJ102V
ERJ3GSYJ102V
ERJ3GSYJ104V
ERJ3GSYJ472V
ERJ3GSYJ104V
ERJ3GSYJ472V
ERJ3GSYJ103V
ERJ3GSYJ221V
ERJ3GSYJ223V
ERJ3GSYJ222V
ERJ3GSYJ104V
ERJ3GSYJ103V
ERJ3GSYJ331V
ERJ3GSYJ271V
ERJ3GSYJ271V
ERJ3GSYJ331V
ERJ3GSYJ473V
EXBV4V102JV
ERJ3GSYJ103V
ERJ3GSYJ274V
ERJ3GSYJ912V
ERJ3GSYJ123V
ERJ3GSYJ562V
ERJ3GSYJ682V
R526 RK3066
R527 RK3027
R528 RK3050
R529 RK3066
R530 RK3027
R531 RA0008
R532 RA0009
R533 RA0009
R534 RK3054
R535 RK3027
R536, RK3061
R537 RK3055
R538 RK3092
R540 RA0008
R541 RK3058
R541 RK3061
R542 RK3091
R543 RK3054
R544 RK3074
R545 RK3027
R546 RA0009
R547 RK3074
R548 RK3038
R549 RK3038
R550 RA0009
R551 RA0008
R552 RA0009
R553 RA0009
R554 RK3055
R555 RA0008
R556 RK3031
R557 RK3052
R558 RK3052
R559 RK3031
R560 RA0009
R561 RK3038
R562 RK3052
R563 RK3031
R564 RK3031
R565 RA0009
R566 RA0010
R567 RA0010
R568 RK3038
R569 RK3050
R570 RK3089
R571 RK3058
R571 RK3061
R572 RK3058
R573 RK3038
R574 RK3055
R575 RK3001
R576 RK3038
R577 RK3038
R578 RK3038
Description
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
CPU unit
Parts Name
ERJ3GSYJ224V
ERJ3GSYJ121V
ERJ3GSYJ103V
ERJ3GSYJ224V
ERJ3GSYJ121V
EXBV4V102JV
EXBV8V102JV
EXBV8V102JV
ERJ3GSYJ223V
ERJ3GSYJ121V
ERJ3GSYJ823V
ERJ3GSYJ273V
ERJ3EKF7502V
EXBV4V102JV
ERJ3GSYJ473V
ERJ3GSYJ823V
ERJ3EKF3902V
ERJ3GSYJ223V
ERJ3GSYJ105V
ERJ3GSYJ121V
EXBV8V102JV
ERJ3GSYJ105V
ERJ3GSYJ102V
ERJ3GSYJ102V
EXBV8V102JV
EXBV4V102JV
EXBV8V102JV
EXBV8V102JV
ERJ3GSYJ273V
EXBV4V102JV
ERJ3GSYJ271V
ERJ3GSYJ153V
ERJ3GSYJ153V
ERJ3GSYJ271V
EXBV8V102JV
ERJ3GSYJ102V
ERJ3GSYJ153V
ERJ3GSYJ271V
ERJ3GSYJ271V
EXBV8V102JV
EXBV8V472JV
EXBV8V472JV
ERJ3GSYJ102V
ERJ3GSYJ103V
ERJ3GSYJ912V
ERJ3GSYJ473V
ERJ3GSYJ823V
ERJ3GSYJ473V
ERJ3GSYJ102V
ERJ3GSYJ273V
ERJ3GSY0R00V
ERJ3GSYJ102V
ERJ3GSYJ102V
ERJ3GSYJ102V
45
T
E
E
T
T
Ver.
SW591UU0018
SW592UU0018
CN501 UE0255
Ref No Parts No.
R579 RK3038
R580 RA0009
R581 RK3062
R582 RK3062
R583 RK3024
R584 RK3024
R585 RK3024
R586 RK3024
SW501UU0019
SW502UU0019
SW503UU0019
SW504UU0019
SW505UU0018
SW506UU0018
SW507UU0018
SW508UU0018
SW509UU0018
SW510UU0018
SW511UU0018
SW512UU0018
SW513UU0018
SW514UU0018
SW515UU0018
SW516UU0018
SW517UU0018
SW518UU0018
SW519UU0018
SW520UU0018
SW521UU0018
SW522UU0018
UP0280
X501 XB0020
X502 XQ0072
X503 XQ0077
MIC501EY0014
W503 MRCL02A
W504 MBCL02A
TL0016
TN0003
YX0004
YX0004
R587 RK3062
UP0280D
SW Unit
Switch
Switch
Connector
Chip R.
Description
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Chip R.
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
Switch
P.C.B.
Ceralock
Ceralock
Ceralock
Mic
Wire
Wire
S0P-112HST
S0P-112HST
6027B-03Z003
CPU unit/SW unit
Parts Name
ERJ3GSYJ102V
EXBV8V102JV
ERJ3GSYJ104V
ERJ3GSYJ104V
ERJ3GSYJ680V
ERJ3GSYJ680V
ERJ3GSYJ680V
ERJ3GSYJ680V
SKQLLC
SKQLLC
SKQLLC
SKQLLC
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
S0P-112HST
DJG5P.C.B.
CSAC4.19MGC-TC
38C4.0000MHZ
38C3.686400MHZ
EM-123A
#30R02-20-02
#30B02-20-02
SheetDJG5
Front shield DJG5
Tape DJG5
Tape DJG5
ERJ3GSYJ104V
Ver.
C601 CU3031
C602 CU3001
C603 CU3010
C604 CU3010
C605 CU3031
C606 CU3005
C607 CU3029
C608 CU3004
C609 CU3031
C610 CU3031
C611 CU3011
C612 CU3004
C613 CU3031
D601 XD0293
D602 XD0293
D603 XD0293
D604 XD0292
D605 XD0293
L601 QKA25A
L602 QA0120
Q601 XT0137
Q602 XT0137
Q603 XT0138
Q604 XU0063
Q605 XU0063
R601 RK3062
R602 RK3050
R603 RK3050
R604 RK3050
R605 RK3037
R606 RK3030
R607 RK3042
R608 RK3050
R609 RK3042
R610 RK3061
R611 RK3050
R612 RK3037
UT0030
TS0097
TN0002
Ref N Parts No.
UVCO unit
Description Parts Name
U VCO Unit
Chip C.
C1608JB1H471KTA
Chip C.
C1608CH1H0R5CTA
Chip C.
C1608CH1H090CTA
Chip C.
C1608CH1H090CTA
Chip C.
C1608JB1H471KTA
Chip C.
C1608CH1H040CTA
Chip C.
C1608JB1H331KTA
Chip C.
C1608CH1H030CTA
Chip C.
C1608JB1H471KTA
Chip C.
C1608JB1H471KTA
Chip C.
C1608CH1H100CTA
Chip C.
C1608CH1H030CTA
Chip C.
C1608JB1H471KTA
Vari Cap
1SV257(TPH3)
Vari Cap
1SV257(TPH3)
Vari Cap
1SV257(TPH3)
Vari Cap
1SV255(TPH4)
Vari Cap
1SV257(TPH3)
Coil
MR1.5 2.5T 0.4
Coil
657BN-1126GHR=P3
Transistor 2SC5065-0(TE85L)
Transistor UN9211TX
Transistor UN9211TX
Chip R.
ERJ3GSYJ104V
Chip R.
ERJ3GSYJ103V
Chip R.
ERJ3GSYJ103V
Chip R.
ERJ3GSYJ103V
Chip R.
ERJ3GSYJ821V
Chip R.
ERJ3GSYJ221V
Chip R.
ERJ3GSYJ222V
Chip R.
ERJ3GSYJ103V
Chip R.
ERJ3GSYJ222V
Chip R.
ERJ3GSYJ823V
Chip R.
ERJ3GSYJ103V
Chip R.
ERJ3GSYJ821V
0.6 pin
VCO Case DJG5
VCO Shield
46
Ver.
V VCO Unit
C701 CU3031 Chip C.
C702 CU3001 Chip C.
C703 CU3031 Chip C.
C704 CU3031 Chip C.
C705 CU3026 Chip C.
C706 CU3004 Chip C.
C707 CU3031 Chip C.
C708 CU3031 Chip C.
C709 CU3010 Chip C.
C710 CU3011 Chip C.
C711 CU3003 Chip C.
C712 CU3010 Chip C.
C713 CU3005 Chip C.
D701 XD0293 Vari Cap.
L701 QA0120 Coil
L702 QKA25A Coil
Q701 XT0137
Transistor
Q702 XT0137
Transistor
Q703 XT0138
Transistor
Q704 XU0063 Transistor
Q705 XU0063 Transistor
R701 RK3062 Chip R.
R702 RK3050 Chip R.
R703 RK3050 Chip R.
R704 RK3050 Chip R.
R705 RK3030 Chip R.
R706 RK3042 Chip R.
R707 RK3050 Chip R.
R708 RK3037 Chip R.
R709 RK3061 Chip R.
R710 RK3042 Chip R.
R711 RK3050 Chip R.
R712 RK3037 Chip R.
UT0030
TS0097
TN0002
C1608JB1H471KTA
C1608CH1H0R5CTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608CH1H181JTA
C1608CH1H030CTA
C1608JB1H471KTA
C1608JB1H471KTA
C1608CH1H090CTA
C1608CH1H100CTA
C1608CH1H020CTA
C1608CH1H090CTA
C1608CH1H040CTA
1SV257(TPH3)
1SV255(TPH4)
1SV255(TPH4)
1SV257(TPH3)
1SV257(TPH3)
657BN-1126GHR=P3
MR1.5 2.5T 0.4
2SC5065-0(TE85L)
2SC5065-0(TE85L)
2SC5066-0(TE85L)
UN9211TX
UN9211TX
ERJ3GSYJ104V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ103V
ERJ3GSYJ221V
ERJ3GSYJ222V
ERJ3GSYJ103V
ERJ3GSYJ821V
ERJ3GSYJ823V
ERJ3GSYJ222V
ERJ3GSYJ103V
ERJ3GSYJ821V
0.6 pin
VCO Case DJG5
VCO Shield
VVCO unit
Parts Name
CHARGE unit/ PTT unit
Ver. Ref No Parts No. Description Parts Name
CHARGE Unit
C801 CU3031 Chip C.
C1608JB1H471KTA
D801 XD0294 Diode
U2FWJ44N(TE12R)
D802 XD0294 Diode
U2FWJ44N(TE12R)
D803 XD0290 Diode
MA111-TX
D804 XD0294 Diode
U2FWJ44N(TE12R)
D805 XD0130 Diode
DA204UT106
JK801 UJ0015
Jack
HEC2781-010020
Q801 XT0088
Transistor 2SA1213Y-TE12L
R801 RK0004 Chip R.
ERJ6GEYJ180V
R802 RK3038 Chip R.
ERJ3GSYJ102V
#28KH1-045-H1
W801 MKCKH4G Wire
#28BH1-040-H1
W802 MBCK04GGWire
W803 MRCK09G Wire
#28RH1-090-H1
#28BH1-095-H1
W804 MBCKH9G Wire
PTT Unit
IC841 XA0351
IC
24LC16BT-1/SN
R841 RK3062 Chip R.
ERJ3GSYJ104V
R842 RK3062 Chip R.
ERJ3GSYJ104V
S0P-112HST
SW841UU0018 Switch
SW842UU0026 Switch
SW843UU0026 Switch
S0P-112HST
SW844UU0018 Switch
CN841 UP0281
DJG5 CPU-PTT FIex.
47
Ver.
Ver.
T
Quick manual DJG5
T
Registration DJG5T
DJG5T Schematic diagram
Instruction card DJG5T
Lot number seal for box
T
PF0031
PH0009A
PK0059
PS0226
PT0004A
HU0094
HU0096
HU0095
Battery rubber DJG5
Battery case DJG5
Battery lid DJG5
Caution label DJG5
Battery spring A DJG5
Battery spring B DJG5
Battery spring C DJG5
Battery spring D DJG5
02+3FeNi1
P2+16FeBC
LCD Panel DJG5
Jack rubber DJG5
Jack cap DJG5
DC cap DJG5
Dial cap DJG5
Jack metal fixture DJG5
Dial knob DJG5
FCC PART15 Seal
T
E
Specification Sheet (A) E
Specification Sheet DJG5T
Antenna EA41
Parts
Parts Name
Parts
Carton DJG5
Carton ,10 sets DR610
Protection bag 5X165X280
Protection bag 5X100X200
Fixture 5sets DR610
Packing
Battery case
Body
EA0041
EG0024
EW0011
EW0012
EW0013
Mechanical
Description
Mechanical
Finished
HK0
HM0153A
HP0028
HP0031
HU0097
FG0203
KD0031
KF0030
PR0282
SD0046
SD0047
SD0048
SD0049
AF0020
AV0003
DP0101
FG0178
FG0179
FG0180
FG0181
FM0100
NK0042
DS0352
DS0363
EA41
EBP33N
EDC63
EDC64
EDC62
PR0237
Ref No Parts No.
AF0020
AX0001
FP0093
FP0094
SC0008
SD0045
TS0100
TS0109A
TS0110
AB0012
AK0001
AN0012
FM0112
KB0058
TS0098
UE0193
FP0069
TS0099
TZ0064
ChargeUnit
Rear Unit
48
02+3FeNil
OP2+4FeBC1
Terminal frame DJG5
Release knob DJG5
Release spring DJG5
Battery terminal DJF5
Earth metal fittings DJG5
VCO earth DJG5
Charge earth DJG5
S26+5FeCr
OB2+4FeN3
Dial nut DJl60
BNC earth DJG5
Rear case DJG5
RF shield DJG5
BNC antenna connector
CPU Shield DJG5
Panel sheet DJG5
Description Parts Name
Front Unit
AP0004
P2+5FeCr
AX0001
OP2+4FeBC1
AX0002
OP2+5FeN1
DG0021
LCD light DJG5
EL0028
XH606
ES0011BZ
SU-36WO824
FG0173
PTT rubber DJG5
FG0174
l6 key rubber DJG5
FG0175
Power key DJG5
FG0176
VOL rubber DJG5
FG0177
V/U key DJG5
FG0182
LCD rubber A DJG5
FG0183
LCD rubber B DJG5
FG0184
ON AIR rubber DJG5
FG0218
Cushion G5
FM0098
Rear panel DJG5
FM0113
CPU earth DJG5
KZ0068Y
Front case DJG5
W501 MKCLH2AAWire
#30K02-025-02
W502 MNCL03AA Wire
#30N02-030-02
ST0052
SP metal fittings DJG5
Ref N Parts No.
Ver.
ADJUSTMENT
1) Required Test Equipment
1. Regulated Power Supply
Supply voltage:
DC 13.8V
Current:
3A or more
10. Distortion Meter/SINAD Meter
Measurable frequency: 1kHz
Input level:
Up to 40dB
Distortion level:
1 % ~1 00%
2. Digital Multimeter
Voltage range:
FS =20V or so
Input resistance:
High Impedance
11. Frequency Counter
Measurable frequency: Up to 500MHz
Measurements stability: +/-0.1 ppm or so
3. Oscilloscope
Measurable frequenc Audio Frequency
4. Audio Dummy Load
Impedance:
8 ohm
Dissipation:
1W or more
Jack:
3.5 mm
12. Linear Detector
Measurable frequency: Up to 500MHz
Characteristics:
Flat
CN:
60dB or more
5. SSG
Output frequency:
Output level:
Moduration:
1GHz or more
-20dB/0.1 uV to 120dB/1V
AM/FM
6. Spectrum Analyzer
Measuring range:
Up to 2GHz or more
7. Power Meter
Measurable frequenc Up to 500MHz
Impedance:
50 ohm, unbalanced
Measuring range:
-10W
Note
1. Standard Modulation: 1kHz +/- 3.5kHz/DEV
2. Reference Sensitivity: 12dB SINAD
3. Attach the fuse to the RF test equipment.
4. All SSG output is indicated by EMF.
8. Audio Voltmeter
Measurable frequenc ~100kHz
Sensitivity:
1mV~10V
9. Audio Generator
Output frequency:
Output impedance:
67Hz~10kHz
600 ohm , unbalanced
Page 49
2) Adjustment for DJ-G5TIE
Item
Condition
RX
Measurement
Equipment
Digital
Multimeter
Digital
Multimeter
TX
Low
Freq. Counter
Power Meter
RF
VC51
RX
SSG
Dist. Meter
RF
Turn the coils
L81L82 to the max.
RX
SSG
TX/RX
Reference
Voltage
Reference
Frequency
Sensitivity
S Meter
HiPower
13.8VDC
L band
f=l45.05MHz
R band
f=435.05MHz
R band
f=435.05MHz (E)
f=445.05MHz (T)
L band
f=144.95MHzSSG
out: -10dBu
L band
f=144.95MHz
Mod: 3.5kHz/dev
SSG out: 3dBu
R band
f=434.95MHz
Mod: 3.5kHz/dev
SSG out: 3dBu
f=435.05MHz (E)
f=445.05MHz (T)
Mid Power
Low Power
High Power
13.8VDC
Mid Power
Low Power
Deviation
DTMF
Subaudible
Tone
Tone
Burst
f=145.05MHz
RX
TX
High
TX
Mid
TX
Low
TX
High
TX
Mid
TX
Low
f=435.05MHz (E)
f=445.05MHz (T) TX
Mod: 1kHz,50mV Low
f=l45.05MHz
Mod: 1kHz,50mV
f=l45.05MHz
Push1"key"
f=145.05MHz
88.5Hz
f=145.05MHz
PushPTT2"key"
Power Meter
Power Meter
Linear Det
Oscilloscope
Power Meter
Unit
V-VCO
P/D
U-VCO
P/D
Unit
Adjustment
Pans
Method
Specifications
V-VCO L701
3.7V
3.7V+/-0.1V
U-VCO L601
1.2V
1.2V+/-0.1V
435.05MHz (E)
445.05MHz (T) +/-50Hz
S Meter IF
RF
RF
IF
SINAD is12dBor more
VR304
3digits should
be turned ON.
VR302
3digits should
be turned ON.
VR51
5.0W
5.OW+/-0.lW
VR52
1.0W
1.0W+/-0.1W
Check
100-400mW
VR53
5.0W
5.0W+/-0.1W
VR54
1.0W
1.0W+/-0.lW
Check
100-400mW
VR306
4.5kHz/DEV
4.5kHz+/-0.1kHz/DEV
VR305
4.5kHz/DEV
4.5kHz+/-0.1kHz/DEV
VR308
3.1kHz/DEV
3.1kHz+/-0.1kHz/DEV
VR307
800Hz/DEV
800Hz+/-50Hz/DEV
VR309
3.0kHz/DEV
3.OkHz+/-0.1kHz/DEV
Page 50
UU0026
UU0026
VOLTAGE TABLE
1) Diode
D51
D53
D56
D57
D59
D61
D64
D63
D74
D52
D55
D58
D60
D62
D65
D66
D67
D68
D69
D70
D71
D72
D76
D77
D301
D302
D310
1
0
0
0
1.21
3.36
2.66
1.04
2
0
2
3.57
3.57
0.03
1.85
0
0
1.86
0
0.91
3
3.57
3.57
0.03
0
4.14
3.47
0
2.76
0.91
Note
UHF LOW TX
VHF LOW TX
UHF LOW TX
R:433.00MHz
VHF TX
L:433.00MHz
L:433.00MHz
L:144,00MHz
VHF LOW TX
1
Di
2
3
Anode Cathode Note
1.69
0.84 UHF TX
0.84
0 UHF TX
2.57
1.82 R:430M RX
2.65
1.9 R:140M RX
1.89
1.15 L:430M RX
1.84
1.1 L:140M RX
0
3.44 L: 145.00MHz when receiving
0
0
0
2.65
1.89 L:140M RX
0
0.85 VHF TX
1.7
0.85 VHF TX
0
0.76 R:140M RX
0
0.75 L:140M RX
1
1.98
1.95
0.76
2
0
0
0.2
3 Note
2.14
2.18
0.2 L:UHF,R:UHF
1
Di
2
D303
D304
D305
D306
D501
D502
D510
D512
Anode Cathode Note
3.44
3.42
3.19
8.03
8.03
6.44
3.24
6.44
1
3.45
3.46
0
0
2
3.39
3.38
0
0
3
2.23
2.29
0
0
D307
D308
3
Anode Cathode Note
8.03
3.18
0
0
4 Note
1.41 L SQL:OFF
1.39 R SQL:OFF
0
0
1
Di
3
D503
D504
D505
D506
D507
D508
D509
Anode Cathode Note
3.54 l.51
LAMP:OND51l
3.54
2.07 LAMP:OND513
3.54
1.5 LAMP:OND514
3.54
2.06 LAMP:OND515
3.76
3.73
D517
3.76
3.53
D518
3.54
1.58 LAMP:ON
2
4
Anode Cathode Note
3.54 l.54
LAMP:ON
3.54
1.53 LAMP:ON
3.54 l.53
LAMP:ON
0.24
2.27 TX:ON
3.46
5.03
0
5.03
Page 59
1
0.24
D516
D516
2
0
3 Note
3.46 PTT:ON
1
D516
Anode
D601
D602
D603
D604
D605
0
0
0
0
0
Cathode Note
1.25
1.68
1.68
3.11 R:SUB
3.11 R:SUB
0
0
0
0
0
Cathode Note
1.22
4.34
4.34
2.2 L:SUB
2.2 L:SUB
Anode
D701
D702
D703
D704
D705
2
Anode Cathode
13.57
13.57
13.57
13.56
13.56
13.55
13.56
13.56
D801
D802
D803
D804
1
13.38
D805
2
13.26
3
1
D805
3 Note
13.56 PTT:ON
2
3
2)IC
IC301
IC305
PinNo.
1
2
3
4
5
6
7
8
lC302
PnNo.
1
2
3
4
5
6
7
8
9
10
11
12
Voltage PinNo. Voltage
3.31
9
1.13
2.64
10
0.63
2.58
11
1.29
3.47
12
0.00
2.48
13
0.18
2.47
14
0.00
2.53
15
0.00
3.46
16
1.70
Voltage Note
3.26
2.70
2.80
3.47
1.21 AM
1.20 AM
1.22
1.26
1.26
3.39
3.45
0.87
PinNo.
PinNo. Voltage Note
13
1.57 AM
14
0.00 AM
15
0.00
16
0.37
17
0.69
18
0.52
19
1.60
20
1.55
21
0.00
22
0.00
23
0.00
24
1.36
1
2
3
4
Voltage PinNo.
Voltage
2.47
5
2.48
2.48
6
2.49
2.45
7
2.51
0.00
8
5.00
Page 60
lC303
PinNo.
1
2
3
4
IC304
PinNo.
1
2
3
4
5
6
7
8
9
10
IC309
Pin No.
PinNo.
5
6
7
8
2.50
11
2.51
0.00
12
0.00
2.50
13
2.48
2.50
14
2.50
2.50
15
2.40
2.50
16
2.36
2.45
17
2.49
5.00
18
0.00
0.00
19
0.00
0.00
20
0.00
1
2
3
4
5
Voltage
8.03
3.48
1.57
0
1.54
1
2
3
4
1.62
5
1.71
1.7
6
1.71
1.69
7
1.68
0
8
3.34
IC310
PinNo.
IC311
PtnNo.
Voltage Note
0.86
0.01
0.00
0.00
1
2
IC309
3 4
5
Voltage Note
3.39 AM
0.00
0.86
3.56
IC306
PinNo.
1
2
3
4
Voltage PinNo.
Voltage
2.52
5
2.48
2.51
6
2.50
2.36
7
2.50
0.00
8
5.00
IC307 When receiving
PinNo. Voltage PinNo.
1
0.0
2
0.0
3
0.6
4
0.0
5
6
7
8
Voltage
0.0
2.7
6.2
0.0
IC503
PinNo. Voltage PinNo.
Voltage
67
0
74
3.52
68
1.22
75
3.53
69
2.38
76
3.52
70
3.45
77
3.52
71
1.9
78
3.46
72
2.34
79
3.46
73
0
80
3.45
Voltage Note
PinNo. Voltage Note
1
0
9
0
2
0
10
0
3
0
11
0.11 R:ON
4
0.11
12
0.1 L:ON
5 0.l1
USUB:ON
13
0.1 VMAIN:ON
6
0.11 UMAIN:O
14
0.1 VSUB:ON
7
15
3.57
8
0
16
3.57
Page 61
IC501
PinNo.
1
2
3
4
IC504 TSQ..ON
PinNo. Voltage Pin No. Voltage
1
1.72
13
1.48
2
2.16
14
3.4
3
3.41
15
0
4
1.25
16
1.88
5
1.72
17
1.72
6
1.72
18
1.72
7
3.45
19
1.72
8
1.68
20
2.22
9
1.73
21
1.72
10
0
22
1.72
11
0
23
1.72
12
0
24
2.33
0.95
5
3.45
0
5
1.16
0
7
0.98
0
8
3.53
IC502 DSQ:ON
PinNo. Voltage Pin No. Voltage
1
1.71
6
3.5
2
0
7
0
3
1.72
8
0
4
1.33
9
0
5
0
10
3.51
IC505
PinNo.
1
2
3
4
IC506, IC507, IC510
1
IC506
0
IC507
0
IC510
0
2
0
0
0
3
3.73
0
3.73
4
3.73
13.54
3.73
Voltage Pin No. Voltage
1.17
5
3.45
0
5
1.16
0
7
0.98
0
8
3.53
5
0
3.76
0
IC508 (CPU. PCB)
DC IN: l3.8V
PinNo. Voltage PinNo. Voltage PinNo. Voltage PinNo.
Voltage PinNo.
Voltage
1
4.2
21
3.52
41
3.52
61
0.01
81
3.53
2
0
22
3.52
42
3.52
62
0.01
82
3.52
3
0
23
3.52
43
3.52
63
0.01
83
0.05
4
24
0
44
3.52
64
3.52
84
0.05
5
3.52
25
0
45
3.52
65
3.52
85
0
6
0
26
3.45
46
3.52
66
0.05
86
0
7
1.66
27
0
47
3.52
67
0.05
87
0
8
1.68
28
0.01
48
3.52
68
0
88
3.53
9
3.68
29
0.01
49
3.52
69
3.51
89
5.03
10
0
30
0.11
50
3.52
70
0
90
1.55
11
0
31
3.53
51
3.52
71
0
91
0
12
0
32
3.53
52
0
72
3.53
92
3.52
13
0
33
3.53
53
0
73
0.01
93
5.03
14
0
34
3.53
54
0
74
0.03
94
0
15
0
35
3.52
55
0
75
0.05
95
0
16
3.52
36
0
56
3.52
76
3.52
96
2
17
3.23
37
3.52
57
3.48
77
0
97
1.975
18
3.73
38
3.52
58
0
78
3.52
98
0.17
19
3.52
39
3.52
59
3.5
79
0
99
0.4
20
3.52
40
0
60
3.53
80
0
100
0
VOL: l (V/U), SQL: OPEN (V/U), BS: OFF
IC509
PinNo.
Voltage
1
5.04
2
0
3
3.39
1
TR
2 1 3
Page 62
IC52
PinNo.
1
2
3
4
5
6
7
8
IC841
0
9
0
PinNo.
Voltage PinNo.
Voltage
0
10
0
1
0
5
3.49
0
11
0.09
2
0
6
0
3.57
12
0.09
3
0
7
0
3.57
13
3.57
4
0
8
3.52
3.57
14
3.57
3.57 l5
3.57 L: 145.00MHz LOW POWER
0
16
3.57 R: 433.00MHz LOW POWER
1
2
3
4
5
Voltage PinNo. Voltage PinNo. Voltage PinNo.
Voltage
3.56
6
1.65
11
0
16
1.72
0
7
0
12
3.53
17
0
0
8
2.05
13
3.53
18
2
3.52
9
1.24
14
0
19
3.79
3.56
10
7.35
15
0
20
0
IC53
PinNo.
3) Transistor
Emitter Base
Collector Note
Q51
13.57
13.05
4.02 UHF:TX Q72
Q53
0.00
0.76
2.08 UHF:TX Q73
Q54
0.00
0.77
3.04 UHF:TX Q74
Q55
0.00
0.00
0.00 When locke Q75
Q60
0.00
0.72
1.60 R: RX
Q76
Q61
0.00
0.71
1.84 R:430M Q77
Q62
0.00
0.76
2.98 R:430M Q78
Q63
0.00
0.75
3.01 R:430M Q79
Q64
0.00
0.72
3.14 R:430M Q80
Q65
7.35
7.97
8.03
Q81
Q66
0.00
0.74
2.17 R:RX
Q82
Q67
0.00
0.73
1.95 R:144M Q85
Q68
0.00
0.76
3.04 R:144M Q86
Q69
0.00
0.69
2.91 R:144M
Q70
0.00
0.75
2.28 R:144M
Q52
Q56
Q58
Q59
Q83
Q84
Q301
Q303
Q304
Q306
Q308
Q309
Q310
Q312
Q313
Q315
1
13.05
3.56
3.57
4.00
13.07
4.05
2
4.11
3.56
3.57
4.18
4.14
4.17
3
1.53
0.09
0.09
0.83
1.55
0.86
4
1.01
3.57
3.57
0.25
1.01
0.26
Emitter Base
Collector Note
13.51
12.97
3.57
0.00
0.52
2.33 R:RX
3.58
3.47
0.00 R:RX
0.80
1.38
3.47 R:RX
3.58
0.53
3.47 R:RX
0.00
0.53
2.33 L:RX
3.57
3.47
3.47 L:RX
0.00
3.44
0.00 AM
0.80
1.38
3.47 L:RX
1.20
0.73
3.45 L:RX
Emitter Base
Collector Note
0.00
0.75
2.56 R:144
0.00
0.72
2.17 L:RX
0.00
0.73
1.85 L:430M
0.00
0.74
3.22 L:144M
0.00
0.74
1.84 L:144M
0.00
0.75
2.47 L:144M
0.00
0.73
1.58 L:RX
0.00
0.67
2.92 L:144M
0.00
0.73
1.97 VHF:TX
0.00
0.74
2.72 VHF:TX
13.57
13.07
4.12 VHF:TX
0.00
0.00
0.00 When locked
0.00
0.00
7.97
5
1.60
0.09
0.09
0.03
1.62
0.02
Q316
Q317
Q318
Q320
Q32l
Q322
Q323
Q327
Note
UHF TX
ATT ON
L:VHF ,R:UHF
UHF TX
VHF TX
VHF TX
1
2
TR
3 4
5
Emitter Base
Collector Note
3.58
0.53
3.47 L:RX
0.00
0.59
0.00 FD
13.58
13.00
6.23 AFPC:ON
0.00
3.46
0.00 TX
0.00
3.46
0.00 TX
0.21
0.82
1.62 TX
0.00
2.93
0.00 XBR
3.58
0.00
3.47 UPRl:ON
Page 63
Q302
Q319
Q326
Q328
Q329
1.00
12.98
13.01
3.46
3.47
3.50
2
13.53
13.58
0.00
0.00
3.50
3.00
3.24
3.39
0.20
0.10
0.00
4
2.70
2.91
3.57
3.57
3.57
5
3.25
3.52
3.58
3.58
0.00
Note
1
When receiving
L:VHF,R:UHF
L:VHF,R:UHF
2
TR
3 4
5
G
Q307
Drain
Gate
Source
1.03
3.52
0.02
Q307
S
Q501
Q502
Q509
Q510
Q511
Q512
1
3.45
3.38
13.01
0
0
0
Emitter
Q503
Q504
Q505
0
0
13.55
2
0
0
3.52
0
13.54
5.01
3
0.28
0.31
1.66
2.54
0
0
4
3.46
3.46
1.12
0
3.24
3.5
D
5
3.46
3.45
1.74
0
13.47
5.04
Base
Collector Note
3.48
0.05 VHF TX:OQ506
3.48
0.05 UHF TX:OQ507
12.88
3.51 LAMP:ONQ508
Q601
Q602
Q603
Q604
Q605
Emitter Base
Collector Note
1.49
0.76
3.09
1.48
0.86
3.06 R:SUB
0
0.74
2.48
0
1.95
0.3 R:SUB
0
2.06
0.03
Q701
Q702
Q703
Q704
Q705
Emitter Base
Collector Note
1.48
0.97
3.04
1.48
0.77
3.08 L:SUB
0
0.67
2.44
0
1.62
0.04 L:SUB
0
2.56
0.03
Q801
Emitter Base
Collector
13.76
13.38
13.36
Note
VHF SQL:OFF
UHF SQL:OFF
1
2
TR
F.D:ON
3 4
5
Emitter Base
Collector Note
3.51
2.83
3.44 TX:ON
2.96
3.52
12.92 LAMP:ON
13.61
13.01
3.52
Page 64

Service Manual

Transcription

Similar documents

Alinco DR-130T Service Manual

DJ-195

release notes

Kenwood TM-V708A

Contents / Index Back to Model List FP