FIRE SPRINKLER SYSTEM

SPECIFICATIONS AND
INSTALLATION INSTRUCTIONS
butterball
BB-SC SERIES AND "LEAD FREE" UPBBTSC SERIES
FIRE SPRINKLER SYSTEM
SLO-CLOSE, INDICATING
BUTTERFLY VALVES
RATED FOR INDOOR & OUTDOOR
AND POTABLE WATER SYSTEMS
BUTTERFLY
VALVE
R
76G2
LISTED
OPEN
C
US
APPROVED
IN EVERY VALVE
MILWAUKEE VALVE
Rev. 04/16
S P E C I F I C AT I O N S F O R S L O -C L O S E
ALL
SSLO-CLOSE
P E C BUTTERBALL
IPATENTED
F I C AT
I O N S F O R INSTALLATION
S L O -C
LOSE
(BB-SC)
VALVES...
BUTTERBALL SLO-CLOSE
A. The BBSC can be installed in any orientation in a
piping system using standard National Pipe Threads.
BUTTERBALL SLO-CLOSE
Wrench should be used to hex on the end of valve
INSTALLATION
(BB-SC)
being threaded
to pipe. Pipe
sealants should be used
A. sparingly.
The BBSC can be installed in any orientation in a
system
using
standard
National
Pipe
Threads.
B. piping
The valves
with
internal
switches
can be
easily
wired
Wrench
should
hex
on the end
of valve
in the field.
Theybe
willused
havetotwo
switches,
switch-1
will
being
threaded
to
pipe.
Pipe
sealants
should
be
used
have dual leads on the terminals. This switch is to be
sparingly. to the supervisory circuit of a Listed alarm
connected
B. control
The valves
with
internalwill
switches
can be
easily
panel.
Switch-2
have single
leads
andwired
may
in the
field. They
will have two
switches,
be
connected
to auxiliary
equipment
perswitch-1
directionwill
of
have
dual
leads
on
the
terminals.
This
switch
is
to
be
the local authority having jurisdiction. Cap any
supervisory
connected
to the
a Listed
unused
wire
leads
with wirecircuit
nutsofand
tuckalarm
into
control
panel.
Switch-2
will
have
single
leads
and may
junction box. All connections shall be reviewed
and
auxiliary
be connected
to local
equipment
per direction of
approved
by the
authority
having jurisdiction.
the
local
authority
having
jurisdiction.
Capto any
C. A 14 gage green wire has been fastened
the
unused
wire
leads
with
wire
nuts
and
into
interior of the housing and is to be used as atuck
housing
junction
ground. box. All connections shall be reviewed and
by the local
authority
D. approved
Recommended
type of
wire to having
be usedjurisdiction.
is No.16 Dual
C. Rated
A 14 gage
green
wire
has
been
UL 300V 80 C and 300V 105 C.fastened to the
interior of the
housing
is to be used
as a housing
E. Installation
must
be in and
compliance
with NFPA
72 and
ground.
13, or bonded and grounded per Canadian Electrical
D. Code
Recommended
type of wire to be used is No.16 Dual
Part 1.
Rated
UL
300V
80
C and
300V 105 C. and BBVSC,
F. The BB-SC, BBHSC
(threaded-end)
E. Installation
must
be
in
compliance
NFPA for
72 and
BVHSC (grooved-end) valves arewith
intended
use
13,
bonded and
grounded
per Canadian
Electrical
withorschedule
40 and/or
80 pipe,
sizes 1", 1-1/4",
1Code
Part
1.
1/2", 2" and 2-1/2" per ANSI B36.10.
F. The BB-SC, BBHSC (threaded-end) and BBVSC,
BVHSC (grooved-end) valves are intended for use
INSTALLATION FOR NEW YORK CITY VALVES
with schedule 40 and/or 80 pipe, sizes 1", 1-1/4", 1N.Y.C. special valves have a large flow indicator which
1/2", 2" and 2-1/2" per ANSI B36.10.
points in the direction of the valve disc, indicating open or
closed. The valve should be installed in a position where
INSTALLATION
FOR
NEW YORK CITY VALVES
the
indicator is readily
visible.
N.Y.C. special valves have a large flow indicator which
points in the direction of the valve disc, indicating open or
closed. The valve should be installed in a position where
the indicator is readily visible.
provide slow opening andALL
closing properties in a quarterturn valve. The purpose
is
to eliminate hydraulic shock
PATENTED
andSLO-CLOSE
water hammerBUTTERBALL
in fire protection and
other liquid
VALVES...
systems.
provide slow opening and closing properties in a quarterare
available
withpurpose
or without
aneliminate
internal, pre-wired
turn
valve. The
is to
hydraulic shock
supervisory
tamper
switch
assembly.
When
mounted
and water hammer in fire protection and
other
liquid on
any
slow-close
valve
and
wired,
the
switches
signal
systems.
movement of the valve disc from the full open position.
are available with or without an internal, pre-wired
are
available factory
to a valveWhen
or asmounted
a kit for field
supervisory
tampermounted
switch assembly.
on
installation
on
previously
installed
valves.
any slow-close valve and wired, the switches signal
movement of the valve disc from the full open position.
have switch ratings of:
Amps/115
VAC-60
are available10factory
mounted
to aHz
valve or as a kit for field
VDC
installation0.5
onAmps/28
previously
installed valves.
are
with tamper
switch assemblies FOR
haveequipped
switch ratings
of:
INDOOR AND
OUTDOOR
USE.Hz
10 Amps/115
VAC-60
0.5 Amps/28 VDC
have UL/FM ratings to 175 psi. (Also available at 350 psi
and
500 psi with
with tamper
N.Y.C.B.S.A.
are
equipped
switchapproval.)
assemblies FOR
INDOOR AND OUTDOOR USE.
have UL/FM ratings to 175 psi. (Also available at 350 psi
and 500 psi with N.Y.C.B.S.A. approval.)
APPROVED
C
US
C
US
For use with fire protection sprinkler systems 175psi.
Approved by the New York City Board of Stds. &
APPROVED
Appeals under Calendar No. 996-81 -SM, for 175 psi and
Calendar
number
350 psi and
500 psi.
For use with
fire720-83-SA
protectionfor
sprinkler
systems
175psi.
(500 psi rated valves not shown.)
Approved by the New York City Board of Stds. &
Appeals under Calendar No. 996-81 -SM, for 175 psi and
Calendar number 720-83-SA for 350 psi and 500 psi.
(500 psi rated valves not shown.)
The information presented on this sheet is correct at the time of publication. Milwaukee Valve reserves the right to change
design, and/or material specifications without notice. For the Installation, Operation and Maintenance Manual (IOM) see the
Technical/Service Information section on our website. For the most current information access www.milwaukeevalve.com
2
MILWAUKEE VALVE
butterball
%877(5)/< 9$/9(6
9$/9(6 /(66 683(59,625< 7$03(5 6:,7&+ $66(0%/<36,
´
%877(5)/<
9$/9(
%877(5)/<
9$/9(
³.´
0$;
5
*
LISTED
23(1
%877(5)/<
9$/9(
%877(5)/<
9$/9(
5
*
LISTED
23(1
5
*
LISTED
23(1
5
*
LISTED
23(1
³)´
´%
³%´
´&
³&´
´:
³:´
´$
³$´
³´'
'´
´+
³+´
³+´
´0 ³/´
´/
³0´
´)
³)´
³(´
³*´
´*
³*´
%%96&
8QLERG\ ZLWK
*URRYHG (QGV
6L]H ´
%%96&
SLHFH ZLWK
*URRYHG (QGV
6L]H ´
%%6& 7KUHDGHG (QGV
6L]HV ´ ´ ´ ´´
9$/9(6 :,7+ 683(59,625< 7$03(5 6:,7&+ $66(0%/<36,
´
)/2:
)/2:
´
´
%877(5)/<
9$/9(
%877(5)/<
9$/9(
*
LISTED
23(1
*
LISTED
23(1
5
5
³-´
´&
³&´
³-´ 3/86 ,1&+
%877(5)/<
9$/9(
%877(5)/<
9$/9(
5
*
LISTED
23(1
5
*
LISTED
23(1
³(´
³)´
´+
³+´
³+´
³´''´
³$´
³:´
7+5($'(' (1'6
%%6&6
1<& ,1',&$725
$YDLODEOH RQ ERWK VZLWFKHG
DQG QRQVZLWFKHG PRGHOV
$// ',0(16,216,1&+(6
7KUHDGHG
6,=(
$
%
&
'
.
/
0
0
1
:
´
´ ´
¶
0 $5( ',0(16,216 86,1*
6&+('8/( 3,3(
0 $5( ',0(16,216 86,1*
6&+('8/( 3,3(
1 ,6 )/2: 5(6,67$1&(
(;35(66(',1 (48,9$/(17 /(1*7+ 2)
6&+('8/( 3,3(
: ,6 7+( :5(1&+ 0$.(83 /(1*7+
*URRYHG
6,=(
´
$
%
&
'
(
)
*
+
.
/
0 0 1 :
´
12
³*´
´)
³)´
³(´
´*
³*´
%%96&6
8QLERG\ ZLWK
*URRYHG (QGV
6L]H ´
%%96&6
SLHFH ZLWK
*URRYHG (QGV
6L]H ´
0$7(5,$/ /,67
3$57
,QGLFDWRU
+RXVLQJ
%RG\
+DQGOH
'LVF
'LVF 6HDO
6ZLWFK +RXVLQJ
0$7(5,$/
6LQWHUHG ,URQ
%URQ]H
%URQ]H
%UDVV
6WDLQOHVV 6WHHO
(3'0 (ODVWRPHU
'LH &DVW $OXPLQXP
63(&,),&$7,21
)3
$670 $670 7\SH The information presented on this sheet is correct at the time of publication. Milwaukee Valve reserves the right to change
design, and/or material specifications without notice. For the Installation, Operation and Maintenance Manual (IOM) see the
Technical/Service Information section on our website. For the most current information access www.milwaukeevalve.com
3
MILWAUKEE VALVE
butterball
%877(5)/< 9$/9(6
9$/9(6 /(66 683(59,625< 7$03(5 6:,7&+ $66(0%/<36,
´
%877(5)/<
9$/9(
%877(5)/<
9$/9(
³.´
0$;
5
*
LISTED
23(1
%877(5)/<
9$/9(
%877(5)/<
9$/9(
5
*
LISTED
23(1
5
*
LISTED
23(1
5
*
LISTED
23(1
³)´
´%
³%´
´&
³&´
´:
³:´
´$
³$´
³´'
'´
´+
³+´
³+´
´0 ³/´
´/
³0´
´)
³)´
³(´
³*´
´*
³*´
%%9+6&
8QLERG\ ZLWK
*URRYHG (QGV
6L]H ´
%%9+6&
SLHFH ZLWK
*URRYHG (QGV
6L]H ´
%%+6& 7KUHDGHG (QGV
6L]HV ´ ´ ´ ´´
9$/9(6 :,7+ 683(59,625< 7$03(5 6:,7&+ $66(0%/<36,
´
)/2:
)/2:
´
´
%877(5)/<
9$/9(
%877(5)/<
9$/9(
*
LISTED
23(1
*
LISTED
23(1
5
5
³-´
´&
³&´
³-´ 3/86 ,1&+
%877(5)/<
9$/9(
%877(5)/<
9$/9(
5
*
LISTED
23(1
5
*
LISTED
23(1
³(´
³)´
´+
³+´
³+´
³´''´
³$´
³:´
7+5($'(' (1'6
%%+&6
1<& ,1',&$725
$YDLODEOH RQ ERWK VZLWFKHG
DQG QRQVZLWFKHG PRGHOV
$// ',0(16,216,1&+(6
7KUHDGHG
6,=(
$
%
&
'
.
/
0
0
1
:
´
´ ´
¶
0 $5( ',0(16,216 86,1*
6&+('8/( 3,3(
0 $5( ',0(16,216 86,1*
6&+('8/( 3,3(
1 ,6 )/2: 5(6,67$1&(
(;35(66(',1 (48,9$/(17 /(1*7+ 2)
6&+('8/( 3,3(
: ,6 7+( :5(1&+ 0$.(83 /(1*7+
*URRYHG
6,=(
´
$
%
&
'
(
)
*
+
.
/
0 0 1 :
´
12
³*´
´)
³)´
³(´
´*
³*´
%9+6&6
8QLERG\ ZLWK
*URRYHG (QGV
6L]H ´
%9+6&6
SLHFH ZLWK
*URRYHG (QGV
6L]H ´
0$7(5,$/ /,67
3$57
,QGLFDWRU
+RXVLQJ
%RG\
+DQGOH
'LVF
'LVF 6HDO
6ZLWFK +RXVLQJ
0$7(5,$/
6LQWHUHG ,URQ
%URQ]H
%URQ]H
%UDVV
6WDLQOHVV 6WHHO
(3'0 (ODVWRPHU
'LH &DVW $OXPLQXP
63(&,),&$7,21
)3
$670 $670 7\SH The information presented on this sheet is correct at the time of publication. Milwaukee Valve reserves the right to change
design, and/or material specifications without notice. For the Installation, Operation and Maintenance Manual (IOM) see the
Technical/Service Information section on our website. For the most current information access www.milwaukeevalve.com
4
MILWAUKEE VALVE
Ultra
Pure
Butterball Slo-Close For Potable Water
Bronze Butterfly Valve
One-Piece, Full Port
175 PSI
Threaded Ends
TM
A MILWAUKEE VALVE PRODUCT
UPBBTSCW/UPBBTSCS02W 1"-2"
C
WQA tested and Certified
against NSF/ANSI 372
for “lead free” compliance.
APPROVED
4-1/2”
DIMENSIONS
Valve Size
DIM
A
B1
C
D
J2
K
L
M-403
M-804
N-405
W6
1”
2.13
3.16
1.56
1.72
4.16
.66
.83
1.10
.96
2.25
1.13
1-1/4”
2.63
3.31
1.94
2.11
4.16
.73
.90
1.38
1.28
2.00
1.25
1-1/2”
2.88
3.41
2.19
2.38
4.51
.73
.10
1.61
1.50
2.50
1.41
ALL DIMENSIONS-INCHES
2”
3.25
3.63
2.75
3.07
4.76
.79
1.41
2.07
1.94
2.25
1.69
BUTTERFLY
VALVE
“K”
R
76G2
LISTED
OPEN
(MAX
ENTRY)
B
C
“C"
M “L"L
“M"
A
D
Pertains to UPBBTSCW only.
Pertains to UPBBTSCS02W only.
M-40 ARE DIMENSIONS USING SCHEDULE 40
PIPE
4
M-80 ARE DIMENSIONS USING SCHEDULE 80
PIPE
5
N-40 IS FLOW RESISTANCE EXPRESSEDIN
EQUIVALENT LENGTH OF SCHEDULE 40
PIPE
6
W IS THE WRENCH MAKE-UP LENGTH
1
W
2
3
UPBBTSCW
Sizes 1”, 1-1/4”, 1-1/2”, 2”
FEATURES
Slow opening and closing
Quarter turn operation
Water Hammer elimination
Optional internal tamper switch
(Indoor/Outdoor use).
- Signals disc movement
- Factory or Field installation
- 10 Amp / 115 VAC-60 Hz
- 0.5 Amp / 28 VDC
1
4-1/2”
7
4
3
2
BUTTERFLY
VALVE
R
76G2
LISTED
OPEN
J
5
C
“C"
6
MATERIALS LIST
ITEM
PART
1
In d ica to r
2
H o u s in g
3
Bo d y
4
H a n d le
M ATERIALS
Iro n
Bro n ze
Bro n ze
ASTM B1 7 6 U N S
C85800
ASTM A2 7 6 ,
Sta in le s s Ste e l
Typ e 3 0 4
EPD M
Bra s s
5
D is k
6
D is k Se a l
Sw itch H o u s in g
Alu m in u m
(BB-SC S0 2 )
7
D
ASTM SPEC.
F0 0 0 8 P
ASTM 5 8 4 U N S
C89833
A
W
UPBBTSCO2W
(Includes Switch)
Sizes 1”, 1-1/4”, 1-1/2”, 2”
Milwaukee Valve Company
16550 W. Stratton Drive
New Berlin, WI 53151
Phone: 262-432-2700
Fax: 262-432-2701
Note: Lead free refers to the wetted surface of the pipe, fittings and fixtures in potable water systems that have a weighted
average lead content ≤ 0.25%. Source: California Health and Safety Code (116875).
The
The information
information presented
presented on
on this
this sheet
sheet is
is correct
correct at
at the
the time
time of
of publication.
publication. Milwaukee
Milwaukee Valve
Valve reserves the right to change
design,
design, and/or
and/or material
material specifications
specifications without
without notice.
notice. For
For the
the Installation,
Installation, Operation
Operation and
and Maintenance
Maintenance Manual
Manual (IOM)
(IOM) see
see the
the
Technical/Service
Information
sectionFor
onthe
ourmost
website.
For information
the most current
information
access www.milwaukeevalve.com
engineering section
on our website.
current
access
www.milwaukeevalve.com
5
UP-36
MILWAUKEE
MILWAUKEE
VALVEVALVE
US
WIRING DIAGRAM
(SWITCH POSITION VALVE FULL OPEN)
SWITCH 1: DUAL LEADS
BLACK
LISTED FIRE ALARM
CONTROL PANEL
SUPERVISORY CIRCUIT
TO NEXT INDICATOR
OR
END OF LINE RESISTOR
NC
WHITE
COM
NO
RED
SWITCH 2: SINGLE LEADS
AUXILIARY
EQUIPMENT
ORANGE
NC
BLUE
VOLTAGE
SOURCE
COM
NO
YELLOW
Green Lead provided is ground for switch housing
Switch Rating: 10 AMP/115 VAC
.5 AMP/28 VDC
Cap unused leads with wire nuts and tuck inside junction box (not provided)
NOTE: Valves incorporating supervisory tamper switches are for indoor and outdoor use.
1/2" ELECTRICAL
CONDUIT
SUPERVISORY TAMPER
SWITCH
OPEN
0.5 AMPS - 28VDC
10 AMPS-115 VAC
S
H
U
T
BB-SCS SERIES
INDOOR/OUTDOOR USE
MILWAUKEE
VALVE CO.
U.S. PATENT
4,518,088
UL LISTED
JUCTION BOX
The information presented on this sheet is correct at the time of publication. Milwaukee Valve reserves the right to change
design, and/or material specifications without notice. For the Installation, Operation and Maintenance Manual (IOM) see the
Technical/Service Information section on our website. For the most current information access www.milwaukeevalve.com
6
MILWAUKEE VALVE