Car Audio DVD520

Transcription

Car Audio DVD520

Car Audio
DVD520
TABLE OF CONTENTS
Page
Technical Specificatio ns ............. .................. .................. ...1-2
Measurem ent setup . .................. .................. .. ...... .......... ...1-3
Service A ids, Safety I nstruction, et c ....... ...... .. ........... 1-4 to 1-5
Preparati ons & Contro ls .............. ......... ...... ... ........... 1-6 to 1-8
Maintena nce & Troub leshooting .. ............... .. .... ............... .. 1-9
Disassem bly Instructi ons & Servic e positions . .... ...... ........ ..... 2
Set Block diagram .... .................. ................ .. .... .............. ..... 3
Set Wirin g diagram ... .................. ....... ...... ..... .................. ..... 4
Key Board ................ .......................... ................................. 5
Servo Board ............. ........................... ...... .......................... 6
Main Boa rd .............. .................. ......... ...... ... .................. ..... 7
Set Mech anical Explo ded view & p arts list .... .. .... .............. ...... 8
1-2
SPECIFICATIONS
Components
General
Power supply:
Maximum power output:
Continuous power output:
Suitable speaker impedance:
Pre-Amp output voltage:
Fuse:
Dimensions(WxHxD)
Weight:
Aux-in level:
Sub-out:
12V DC(11V-16V)
Test voltage 14.4V, negative ground
55Wx4 channels
25Wx4 channels (4Ω10% T.H.D.)
4-8 ohm
4.0V(CD play mode: 1KHz, 0 dB, 10 KΩload)
15A
178x50x166mm
1.7kg
≥300 mV
4.0V
FM Stereo Radio
Frequency range:
Usable sensitivity:
Frequency response:
Stereo separation:
Image response ratio:
IF response ratio:
Signal/noise ratio
87.5-108.0 Mhz (EUROPE MODE)
87.5-107.9Mhz (USA MODE)
65.0 - 74.0 MHz ( OIRT MODE )
8 dBμ
30 Hz-15kHz
30dB(1kHz )
50dB
70dB
>55dB
Disc Player
System:
Frequency response:
Signal/noise ratio:
Total harmonic distortion:
Channel separation:
Video signal format system:
Video:
video output:
horizontal nesowtiou:
Disc digital audio system
20 Hz - 20 kHz
>80 dB
Less than 0.20%(1 kHz)
>60 dB
PAL/NTSC/AUTO
1±0.2V
≥500 lines
Note: Specifications and design are subject to change
without notice for product improvements.
Mounting collar
Tapping screws M5x6 mm
M4x6 mm
Mounting bolt (50 mm)
Wire connector
Removable face plate case
Trim plate
T-key
Operating Instructions
Rubber cushion
Remote controller
1
4
4
1
1
1
1
2
1
1
1
1-3
MEASUREMENT SETUP
Tuner FM
Band pass
250Hz-15kHz
DUT
e.g. 7122 707 4 8001
RF G enerator
LF Voltmeter
e.g. PM2534
e.g. PM5 326
S/N and distortion meter
e.g . Sound Tech nology ST1700B
U se a bandpass filter to el iminate hum(50Hz,100Hz) and disturbance from the pilottone( 19kHz,38kH z).
Tuner AM (MW,LW )
Bandpass
250H z-15kHz
DUT
e.g. 7 122 707 480 01
LF Voltmeter
e.g. PM2 534
RF Gen erator
e.g. PM53 26
S/N and distortion meter
e.g. S ound Techno logy ST1700 B
Frame aeria l
e.g. 71 22 707 8900 1
To avoid atmospheric interference all AM-measurement s have to be carried out in a Faraday 's cage.
Use a bandpass filter ( or at lea st a high pas s filter with 2 50Hz) to eliminate hum ( 50Hz,100Hz ).
CD
Use Au dio Signal Disc SBC429 4822 397 30184
(replac es test disc 3)
DUT
L
R
S/N and dis tortion meter
e.g. Sou nd Technolo gy ST1700B
L EVEL METE R
e.g. Sennheiser UPM550
with FF-fil ter
1-4
HANDLING CHIP COMPONENTS
GENERAL
DISMOUNTING
MOUNTING
e.g. A PAIR OF TWEEZERS
VACUUM PISTON
4822 395 10082
A
SOLDERING
IRON
e.g.WELLER
Solder tip PT-H7
A
SOLDERING
IRON
SLODER
Φ0.5-0.8mm
SLODERING
PRESSURE
IRON
SOLDER WICK
4822 321 40042
SLODERING TIME
< 3 secretary / side
e.g. A PAIR OF TWEEZERS
HEATING
SOLDER
CHIP
COMPONENT
HEATING
SOLDER
B
Φ0.5-0.8mm
PRESSURE
SLODERING
IRON
B
SOLDER
COPPER TRACK
P.C.B
SOLDERING
IRON
GLUE
CLEANING
SOLDER WICK
SOLDERING
IRON
PRECAUTIONS
EXAMPLES
C
CORRECT
CORRECT
COPPER TRACK
SOLDERING
IRON
SOLDERING
IRON
NO！
SERVICE PACKAGE
CHIP COMPONENT
1-5
GB
NL
ESD
WARNING
Alle IC's en vele andere halfgeleiders zijn
gevoelig voor electrostatische ontladingen
(ESD).
Onzorgvuldig behandelen tijdens reparatie kan
de levensduur drastisch doen verminderen.
Zorg ervoor dat u tijdens reparatie via een
polsband met weerstand verbonden bent met
hetzelfde potentiaal als de massa van het
apparaat .
Houd componenten en hulpmiddelen ook op
ditzelfde potentiaal.
All ICs and many other semi-conductors are
susceptible to electrostatic discharges (ESD).
Careless handling during repair can reduce life
drastically.
When repairing, make sure that you are
connected with the same potential as the mass
of the set via a wrist wrap with resistance.
Keep components and tools also at this
potential.
F
WAARSCHU WING
AT TENTION
Tous les IC et beaucoup d'autres
semi-conducteurs sont sensibles aux
decharges statiques(ESD).
Leur longevite pourrait etre considerablement
ecourtee par le fait qu'aucune precaution n'est
prise a leur manipulation.
Lors de reparations,s'assurer de bien etre relie
au meme potentiel que la masse de l'appareil et
enfiler le bracelet serti d'une resistance de
securite.
Veiller a ce que les composants ainsi que les
outils que l'on utilise soient egalement ace
potentiel.
D
I
WARN I NG
Alle ICs und viele andere Halbleiter sind
empfindich gegenuber elektrostatischen
Entladungen(ESD).
Unsorgfaltige Behandlung im Reparaturfall kan
die Lebensdauer drastisch reduzieren.
Veranlassen Sie,dass Sie im Reparaturfall uber
ein Pulsarmband mit Widerstand verbunden
sind mit dem gleichen Potential wie die Masse
des Gerates.
Bauteile und Hilfsmittel auch auf dieses gleiche
Potential halten.
AVVERTIMENTO
Tutti IC e parecchi semi-conduttori sono
sensibili alle scariche statiche(ESD).
La loro longevita potrebbe essere fortemente
ridatta in caso di non osservazione della piu
grande cauzione alla loro manipolazione.
Durante le riparazioni occorre quindi essere
collegato allo stesso potenziale che quello della
massa dell'apparecchio tramite un braccialetto
a resistenza.
Assicurarsi che i componenti e anche gli utensili
con quali si lavora siano anche a questo
potenziale.
GB ATTENTION
Safety regulations require that the set be restored to its original
condition and that parts which are identical with those specified,
be used.
Pour votre securite,ces documents
doivent etre utilises par des specialistes agrees,seuls habilites a reparer
votre appareil en panne .
NL
Veiligheidsbepalingen vereisen,dat het apparaat bij reparatie in
zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,
identiek aan de gespecificeerde,worden toegepast.
CLASS 1
LASER PRODUCT
3 1 22 11 0 03 42 0
F
Les normes de securite exigent que I'appareil soit remis a I' etat
d'origine et que soient utilisees les pieces de rechange identiques
a celles specifiees.
GB
Warni ng!
Invisible laser radiation when open.
Avoid direct exposure to beam.
D
Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu
beachten.Der Original zustand des Gerats darf nicht verandert werden;
fur Reparaturen sind Original-Ersatzteile zu verwenden.
S
Varnin g!
Osynlig laserstralning nar apparaten ar oppnad och sparren
ar urkopplad. Betrakta ej stralen.
SF
Varoit us!
I
Le norme di sicurezza esigono che I'apparecchio venga rimesso
nelle condizioni originali e che siano utilizzati i pezzi di ricambio
identici a quelli specificati.
Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina
nakymattomalle laserisateilylle. Ala katso sateeseen!
DK
After servic ing and befor e returning s et to custom er perform a
leakage curr ent measurement test fro m all expose d metal part s to
earth ground to assure no shock haza rd exist .The leakage curr ent
must not exc eed 0.5mA.
Advar se!
Usynlig laserstra ling ved abning nar sikkerhedsafbrydere er
ude af funktion.Undga udsaettelse for straling.
1-6
PREPARATIONS
Wiring Diagram
Subwoofer out
(Green)
Aux-in(Black)
R(Red)
L(White)
Video-out
Antenna
(Yellow)
Fuse 15A
Connector
Rear Line-out (Gray)
R(Red)
Front Line-out (Brown)
L(White)
R(Red)
Amplif ier
L(White)
Filter Box
ISO Connector
Yellow
To car battery(+)
Continuous +12V DC
Ground Lead
Black
Motor/Electric Antenna relay control Lead
Amplifier relay control Lead
Blue
Red
Purple
Purple/
Black
Stripe
Right Speaker
(Rear)
Gray
Gray/
Black
Stripe
Right Speaker
(Front)
White/ White
Black
Stripe
Left Speaker
(Front)
Ignition key
+12V DC When ON/ACC
Green/
Black
Stripe
For some VW/Audi or Opel(Vauxhall)
car models, you may need to modify
wiring of the supplied power cord as
illustrated, or else the memory of the
unit may be lost af ter you power off.
Contact your authori zed car dealer
before installing this unit.
Original wirin g
Yellow
Yellow
Red
Red
Green
Mo dified wiring
Yellow
Yellow
Red
Red
Left Spea ker
(Rear)
Using the ISO Connector
1.If your car is equipped with the ISO connector, then connect the ISO connectors as illustrated.
2. For connections without the ISO connectors, check the wiring in the vehicle carefully before connecting,
incorrect connection may cause serious damage to this unit.
Cut the connector, connect the colored leads of the power cord to the car battery, as shown in the colour
code table below for speaker and power cable connections
Connector
Connector
1-7
CONTROLS
Power on/off : Press PWR to turn on/off the unit.
Traffic Announcements
Program Type
Press more than 2 seconds
to enter LOCAL mode.
Press to tune in a preset statio n Hold for
more than 2 seconds to store station.
Radio preset
Remote sensor
again to DX mode.
Alternative Frequency
ON/OFF
Power ON/OFF
to enter ST mode.
TA
Radio
PTY
AF
again to MONO mode.
PWR
DN
Aux-in
Disc play
(when disc is in)
Panel Open
AMS
VOL
SRC
Radio tune
UP
DISP
MUTE
1
I NT
RPT
RDM
2
3
4
5
6
To fast search within
a track/ skip to next
or previous track
BAND
Display switch
AMS
Rotate the knob to
adjust volume level
FM1
Push to select VOL/BAS/
TRE/BAL/FAD, Rotate the
knob to adjust level
FM2
FM3
Push more than 2 seco nds
to Menu mode
Press the
FM(OIRT)
button to open the panel and press
Disc Eject
RESET HOLE
Note: Pressing the RESET hole will erase
the clock setting and stored stations.
to eject the disc.
Disc slot: insert a disc for playback here.
Panel status indicat or:
Lights up when you slide the panel down;
Flashes when you remove the panel.
1-8
REMOTE CONTROLS
Power On : Press
button to turn on/off the unit.
Subtitle(DVD only)
Zoom(V CD/DVD only)
Radio
Title(D VD only)
Aux-in
Power on/off
TITLE
DVD Setup
SETU P
Menu cursor
ZOOM
SRC
SUB.T
REPEAT
A B
ENTER
Enter
Disc Play
(when disc inserted)
REPEAT: Title\chapter\disk\track\index
A-B repeatedly
Stop/Return
Program
Play / Pause
PROG
Digit Area
1
ABC
2
DEF
3
GH I
GOTO
4
JKL
5
MNO
6
PQRS
MENU
PBC
7
TUV
8
WXYZ
9
SPACE
OSD
ON Screen display
0
SEEK +
10+
AUDIO
Audio(DVD only)
VOL -
SEL
VOL+
DISP
ON Panel display
MUTE
SE EK -
BAND
P /N
ANGLE
Angle(DVD only)
+-_
SEL(ect) to select basic
sound setting options
Vol / Bas / Tre / Bal / Fad
Goto Search
DVD MENU
PBC (for VCD 2.0 or up)
Volume
Mute
Radio Tune
Video system PAL/NTSC/AUTO
Track Skip / Seek
Radio band
Replacing the lithium battery of remote control unit.
* When the op eratio n rang e of th e card remot e
contr ol bec omes short o r no P roperl y, replace
the li thium battery with a new one. M ake s ure
the b attery polarity replaceme nt is c orrect.
1. Pull out th e batt ery ho lder w hile p ressin g the s toppe r.
2. Inse rt the butto n-type lithium battery wi th the (+)
mar k facin g upw ard. In sert t he bat tery ho lder in to the
rem ote co ntrol.
(CR 2025)
WARNINGS:
S tore t he bat tery in place where children cannot re ach.
I f a chi ld acci dentally swa llows the ba ttery,
c onsul t a doc tor im mediately.
D o not recha rge, sh ort, disasse mble o r heat the battery
o r disp ose it in a fir e.
D oing any of these things may c ause the battery to give
o ff hea t,crack or start a fi re.
D o not leave the ba ttery w ith other me tallic m ateri als.
D oing this ma y cau se the batter y to gi ve off heat, c rack
o r start a fire.
W hen throwing awa y or saving the battery, wrap it in tape
a nd ins ulate; otherwise, th e battery may start to give off
heat, c rack o r start a fire.
D o not poke t he battery with twe ezers or similar to ols.
D oing this ma y cau se the batter y to give off heat, c rack
o r start a fire.
1-9
MAINTENANCE AND TROUBLESHOOTING
Maintenance
Clea ring d isc
When a dis c beco mes d irty cle an it with a c leanin g cloth .
Wipe the di sc from the c enter out.
Clea ning t he dis c lens
After prolon ged u se, dir t or du st may accum ulate at the lens. To ens ure go od pla yback quality, clea n the d isc wit h Philips CD lens
Clea ner or any c omme rcially availa ble cle aner. Follow the in structi ons su pplied with c leaner.
Clea ning t he hea ds an d the Tape Parts
To en sure g ood p laybac k qual ity, cle an the heads A ,th e caps tan B ,
and p ressu re rolle r C a fter ev ery 50 hours of tap e operation. Used
a cot ton sw ab slig htly m oisten ed wit h clea ning flu id or a lcoho l.
You c an als o clea n the h eads by play ing a c leani ng tape once .
Troubleshooting
If you suspect something is wrong, immediately switch power off. Immediately stop using it and call the store where you purchased it.
Never try to repair the unit yourself because it is dangerous to do so.
Radio
General
No power or
no sound
Car's engine switch is not on.
Turn your car's key to ACC or ON.
Cable is not correctly connected.
Check connection.
Fuse is burnt. Replace fuse.
Check volume or mute on / off.
If the above solutions cannot help,
Press the RESET button.
no sound.
Disc sound skips,
tone quality is low.
Disc is upside down.
Place disc in the correct direction,
and the label side up.
Disc is dirty or damaged
Clean disc or change another disc.
Disc is dirty or damaged.
Clean CD or change another CD.
o
Sound skips due
to vibration.
Station is too far, or signals are too weak.
Select other stations of higher signal level.
Preset station
lost
Battery cable is not correctly connected.
Connect the battery cable to the
terminal that is always live.
Error Display Messages
Disc
Disc is inside but
Much noise in
broadcasts
Mounting angle is over 30 .
o
Adjust mounting angle to less than 30 .
Unstable mounting.
Mount the unit securely with the
mounting parts.
Disc is dirty, damaged or upside down.
Press
to eject the disc.
When video file
initializing time
is too long
File read error or file type not supported.
Press SRC to exit. Then press SRC to
play disc again.
2-1
2-1
DISMANTLING INSTRUCTIONS
1 Pull out the short sheet from main set.
2 Remove top and bottom covers.
4 Remove CD loader
Remove 2 pcs
screw on the
top of loader.
Loosen 8 screws to
remove heatsink &
top cover & bottom
cover.
3 Loosen 4 pcs screw to remove Front Cabinet.
Remove 6 pcs
screw on the
main board.
Remove the 2 pcs
screw to dismantle
the frame.
Remove 2 pcs screw
from front cabinet.
Pull out FPC
wire.
Remove the 2 pcs
screw to dismantle
the frame.
Remove the two
connectors from
the mainboard.
2 -2
2-2
DISMANTLING INSTRUCTIONS
Service Position A
Service Position B
Service Position C
Service Position D
3
3
SET BLOCK DIAGRAM
D 5V
D9V
GND
DVD-R
AM /FMOUT
KST-6102
LCD Displ ay
T DA7479
SINGLE CHIP RDS DEMODULATOR+FILTER
PA0
PA1
PC 7/SS
K IN 0-1
1MX16X4BANK
(TSOP1154PIN)
SDRAM
C H ICK-SW
E JEC T-SW
L OAD-SW
DVD-R
DVD-L
LCD Data
EN
D V D-CLK
XI R
CS
DATA
K V5V- ON
LCD Cl ock
LCD Driver
L C 6523
LCD CE
M
MCU D C 5V
VIDEO-OUT
M CU
ST7 2 F3 21 A R9 T6
VIDEO-OUT
AM 5668
Motor Driver
F/ L
DVD- R
SPH E8281D
MCU D C 5V
ACC
M u te
ST-BY
Vcc1
Vcc2
F/ L
MUTE
FLASH MX29LV800T
(TSOP48PIN)
ROM
CDL
CDG CDR
5
AM
DV D-L
CASS R
F/ L
SMUTE
3
11
8
MIXING
STAGE
LOUDNESS
VOLUME
SOFT
MUTE
OUT LR
TREBLE
OUT LF
BASS
OUT RR
1
OUT RF
2
INPUT
MULTIPLEXER
+
AUTO ZERO
CASS L
PHONE
(MPIN)
AUX/CDC-R
AUX- R
4
7
PHONE GND 6
(MPOUT)
N.C.
PHONE
17
19
16
18
12
BEEP
I2C BUS
13
OUT1+
IN1
OUT LR
OUT LF
OUT1-
F/ R
OUT RR
OUT RF
F/ R
SCL
SDA
PW-GND
Pre-Amp
RC4558
IN2
OUT2-
FM R
PW-GND
FML
AUX-L
AUX/CD C-L
CDC-R
9
PILOT
CANCELLATION
80KHz
LP
DEMODULATOR
+ STEREO ADJUST
+ STEREOBLEND
25KHz
LP
S&H
HIGH
CUT
CONTROL
R /R
R/R
OUT3-
IN3
VS
CDC-ON
D5V
PW-GND
15
PLL
14
PIL
DET
CD4066BC
QUAD BILATERAL
OUT4+
D
MULTIPATHDETECTOR
NOISE
BLANKER
PULSE
FORMER
20
A
IN4
R/L
10
GND CREF
R/L
LEVEL
Electric Selector & Volume
TDA7460
GN D
D9V
AC-GND
S-GND
OUT4PW-GND
B5V
D5V
Su b Out
Pre-Amp
RC4558
F/R
Lin e- Output
D9V
Gro und
TAB
F/L
D C 11 ~16V
Pow er Supply
SVR
Po we r Amplif ier
TD A738 4
Pre-Amp
RC4558
Cont rol led Power
DVD +9V
DC 11 ~16V
R /R
OUT3+
SUPPLY
C DC-L
AP1507
MPX
F/ R
OUT2+
R /L
4
SET WIRING DIAGRAM
4
5-1
5-1
LCD PIN CONNECTION
KEY BOARD
TABLE OF CONTENTS
LCD Display..........................................................5-1
Front board...........................................................5-2
connector board....................................................5-2
Key Board Circuit Diagram......................................5-3
Key Board Layout Diagram......................................5-4
Elect rical Parts List.................................................5-5
5-2
5-2
FRONT BOARD - CIRCUIT DIAGRAM
CONNECTOR BOARD - CIRCUIT DIAGRAM
FRONT BOARD - LAYOUT DIAGRAM
CONNECTOR BOARD - LAYOUT DIAGRAM
5-3
KEY BOARD - CIRCUIT DIAGRAM
5-3
5-4
KEY BOARD - LAYOUT DIAGRAM
TOP VIEW
KEY BOARD - LAYOUT DIAGRAM
BOTTOM VIEW
5-4
5-5
5-5
ELECTRICAL PARTS LIST - KEY BOARD
GREEN LIGHT
Part N O.
Description
84-DV D705R S-KB 00-A
ELECTRICAL PARTS LIST - KEY BOARD
RED LIGHT
Q TY
DVD70 5RS-5 8A
1
82-CM 705-KB02-C
CM705 KB SMT
1
11-0102-0R02-0
RMF 0Ω 1/16W ±5% SMT 0603
2
11-0102-102 2-0
RMF 1KΩ1/1 6W ±5 % SM T 060 3
11-0102-103 2-0
Loca tion
Part N O.
D escrip tion
83802 DVD7 05EKB 013
D VD70 5E RED KB S MT As sm
1
Q TY
Loca tion
12160 40000 00
R ES,0Ω ,±5% ,1/16 W,060 3
4
R101 ,R407 ,R301 ~R302
R101 ,R407
12160 40001 02
R ES,1K Ω,±5 %,1/1 6W,06 03
2
R107 ,R117
2
R107 ,R117
12160 40001 03
R ES,10 KΩ,± 5%,1/ 16W,0 603
1
R119
RMF 10KΩ1/ 16W ± 5% SMT 06 03
1
R119
12160 40001 52
R ES,1K5Ω,± 5%,1/ 16W,0 603
2
R108 ,R118
11-0102-152 1-0
RMF 1K5Ω1/ 16W ± 5% SMT 06 03
2
R108 ,R118
12160 40001 81
R ES,18 0Ω,± 5%,1/ 16W,0 603
2
R102 ,R112
11-0102-1811-0
RMF 180Ω1/16W ± 5% SM T 0603
2
R102 ,R112
12160 40002 20
R ES,22 Ω,±5 %,1/1 6W,06 03
4
R120 ~R123
11-0102-220 2-0
RMF 22Ω1/16W ±5% SM T 0603
4
R120 ~R123
12160 40002 21
R ES,22 0Ω,± 5%,1/ 16W,0 603
2
R103 ,R113
11-0102-2211-0
RMF 220Ω1/16W ± 5% SM T 0603
2
R103 ,R113
12160 40002 22
R ES,2K2Ω,± 5%,1/ 16W,0 603
1
R109
11-0102-222 2-0
RMF 2K2Ω1/ 16W ± 5% SMT 06 03
1
R109
12160 40003 31
R ES,33 0Ω,± 5%,1/ 16W,0 603
2
R104 ,R114
11-0102-3311-0
RMF 330Ω1/16W ± 5% SM T 0603
2
R104 ,R114
12160 40003 32
R ES,3K3Ω,± 5%,1/ 16W,0 603
1
R110
11-0102-332 2-0
RMF 3K3Ω1/ 16W ± 5% SMT 06 03
1
R110
12160 40004 71
R ES,47 0Ω,± 5%,1/ 16W,0 603
2
R105 ,R115
11-0102-4711-0
RMF 470Ω1/16W ± 5% SM T 0603
2
R105 ,R115
12160 40004 73
R ES,47 KΩ,± 5%,1/ 16W,0 603
3
R139 ,R201 ,R202
11-0102-473 2-0
RMF 47KΩ1/ 16W ± 5% SMT 06 03
3
R139 ,R201 ,R202
12160 40006 81
R ES,68 0Ω,± 5%,1/ 16W,0 603
2
R106 ,R116
11-0102-6811-0
RMF 680Ω1/16W ± 5% SM T 0603
2
R106 ,R116
12160 60004 71
R ES,47 0Ω,± 5%,1/ 10W,0 805
10
R125 ~R133，R1 41
11-0103-4711-0
RMF 470Ω1/10W ± 5% SM T 0805
10
R125 ~R133 ，R1 41
12160 60006 81
R ES,68 0Ω,± 5% ,1/10W,0 805
4
R134 ~R137
11-0103-6811-0
RMF 680Ω1/10W ± 5% SM T 0805
4
R134 ~R137
12180 30001 02
C AP,1n F,±10 %,16V,X7R, 0603
1
C101
11-0202-102 1-0
CC100 0PF/50V ±1 0% 0603(X7R)
1
C101
12180 60001 05
C AP,08 05,10 5,50V, Y5V,+ 80%-2 0%
3
C102 ,C103 ,C104
11-0203-105 1-0
CC 1μ F/25V -80% +20% SMT 0 805
3
C102 ,C103 ,C104
14340 50000 69
L ED,RE D,060 3,10m A,2.2 V
21
(at G positi on)D1 01~D115,D1116,D117~D 121
11-0406-000 5-A
L ED 2.2V 10MA GR EEN S MT 06 03
21
D101 ~D121
14240 00003 38
IC,SC7 5823E ,QFP- 64-14 X14-0 .8,SL
1
IC10 1
11-0901-006 5-A
IC PT6523 LCD DRIVE
1
IC10 1
14301 00303 97
K B,CM 705,FR 4,183 .2X16 0.8mm ,1.2m m
1
11-1821-059 4-C
PCB CM 705 KB D/S 1.2MM VER.2
1
11-2011-002 5-0
TACT SW 250 GF 4. 3MM(SMT)C HIFENG （Difeng）
11-0103-7511-0
RMF 750Ω1/10W ± 5% SM T 0805
11-0102-101 2-0
14321 00000 50
TACTS W,4.3m m,TS -03M-AH-A,250GF
17
SW1 01~SW117
SW1 01~SW 117
12160 40007 51
R ES,75 0Ω,± 5%,1/ 16W,0 603
1
R140
1
R140
12160 40001 01
R ES,10 0Ω,± 5%,1/ 16W,0 603
1
R145
RMF 100Ω1/16W ± 5% SM T 0603
1
R145
14166 20000 08
E NCODER,E CB12, (7X5)( PV)S1 7
1
EN10 1
11-0181-001 0-A
ECB12 (7X5)(PV)S17
1
EN10 1
14340 50000 57
L ED,WHITE,F CWHWAO-AO,25 MA,3. 5V
2
D126 ,D127
11-0406-003 2-0
L ED 3.5V 25MA WHITEΦ3MM (FCWH WAO- AO)
2
D126 ,D127
12340 00100 08
D VD70 5,NEG ATIVE COL OUR (SA)
1
LCD101
11-2602-003 0-0
L CD DVD705 NEGATIVE COLO UR (SA)
1
LCD1 01
12380 50000 16
1 4PIN, 2.0mm ,SOC KET M ALE E STF2- 14-01 (90°)
1
CON 101
17
6-1
SERVO BOARD
TABLE OF CONTENTS
Circuit Diagram..........................................................6-2 to 6-4
PCB Layout ........................................................................6-5
Electrical Parts List..............................................................6-6
6-1
6-2
SERVO BOARD - CIRCUIT DIAGRAM
6-2
6-3
6-3
6-4
6-4
6-5
SERVO BOARD - LAYOUT DIAGRAM
TOP VIEW
6-5
SERVO BOARD - LAYOUT DIAGRAM
BOTTOM VIEW
6-6
6-6
ELECTRICAL PARTS LIST - SERVO BOARD
Part N O.
Description
QTY
Loca tion
QT Y
Lo cation
Par t NO.
D escrip tion
121 80300 0683
C AP,0.068μF,±10% ,50V,X7R,0 603
1
C51
83802 DVD7 05ESB 051 DVD705E DIVX (DVD705E-58A) SB SMT Assm
1
12160 40000 00
RES,0Ω,± 5%,1/16W,0603
6
R1 R 3 R89 R100 R103 R 104
121 80300 0821
C AP,06 03,82 0pf,±1 0%,1 6V,X7 R
1
C71
12160 40001 00
RES,10Ω ,±5%,1/16W,0603
2
R112 R175
121 84509 0107
TAN.CA P,100 μF,± 20%,6 .3V,C
6
EC26 EC24 EC25 EC29 EC30 EC 39
12160 40001 01
RES,100Ω ,±5% ,1/16W,0603
3
R163 R242 R243
122 00000 0179
INDUC TOR,1 .8μH, ±10% ,50MA ,0805
1
L2
12160 40101 02
RES,1kΩ ,±1%,1/16W,0603
6
R19 R24 R2 9 R16 R67 R 247
122 04000 0011
C HIP B EAD,0 603,1 .6X0.8 X0.8,800mA,100M HZ,0. 6
12160 40001 03
RES,10KΩ ,±5%,1/16W,060 3
9
R17 R20 R9 2 R93 R94 R 244 R 38 R9 R11
122 04000 0061
C HIP B EAD,1 20Ω,L 2XW1 .25XT 1.25X A0.5,3 A,
12160 40003 32
RES,3K3Ω ,±5%,1/16W,060 3
4
R13 R26 R1 28 R1 31
12160 40101 22
RES,1K2Ω ,±1%,1/16W,060 3
1
R122
12160 40001 52
RES,1K5Ω ,±5%,1/16W,060 3
1
R114
12160 40001 53
RES,15KΩ ,±5%,1/16W,060 3
4
R71 R72 R1 0 R23
142 24500 0015
12160 40001 54
RES,150KΩ,±5%,1/16W,06 03
2
R22 R34
142 20600 0020
12160 40000 10
RES,1Ω,± 5%,1/16W,0603
1
R32
12160 40003 93
RES,39KΩ ,±5%,1/16W,060 3
1
12160 40002 03
RES,20KΩ ,±5%,1/16W,060 3
1
12160 40003 30
RES,0603,33Ω,±5%,1/16W
1
12160 40003 33
RES,33KΩ ,±5%,1/16W,060 3
1
12160 40003 91
RES,390Ω ,±5% ,1/16W,0603
1
12160 40004 33
12160 40000 47
12160 40004 72
RES,4K7Ω ,±5%,1/16W,060 3
10
L9 ,L10,L12,L13,L18, L19,L2 2,L26 L29,L16
3
L2 0,L28,L38
5
L5 L6 L25 L27 L36
T R，DT C343 TK，S OT－2 3
1
Q14
S W DIO DE, 1 N4148 , 25ｍ A.0.9V, 100V, MINI-MELF
7
D8 D9 D10 D2 D3 D4 D6
142 25100 0001
T R，2N 3904（ NPN ），SO T－23
1
Q 33
R127
142 24500 0003
T R,2N3 906(P NP),S OT-23
2
Q8 Q32
R118
122 29000 0031
T R,2SB 1132, SOT-8 9
2
Q11 Q13
R105
142 40000 0541
IC,AT24C02,SOP-8
1
U6
R124
142 40000 0416
IC,UTC 4558, SOP-8 ,UTC
1
U1
R113
142 40000 0108
IC,BA6 287F,S OP-8 ,ROMH
1
U3
RES,43KΩ ,±5%,1/16W,060 3
1
R126
142 40000 0504
IC,UTC 1117-3.3V,S OT-23 ,UTC
1
U11
RES,4Ω7,±5%,1/16W,0603
2
R87 R97
142 40000 0505
IC,UTC 1117-1.8V,S OT-22 3,UTC
1
U14
R66 R130 R134 R246 R 249 R14 R2 7
142 40000 0179
IC,IS42 S1640 0A,TSOPII- 54,ISS I
1
U5
R101 ~R102 R36 R37
142 41000 0024
IC,AM5 668S, HSOP 28,AM TEK
1
U4
11
1 00MH Z,DCR 17Ω
122 04000 0042
C HIP B EAD,0 805,2 .0X1.2 X0.9X 0.5,20 0mA,
1 00MH Z,0.40 Ω
12160 40004 74
RES,470KΩ,±5%,1/16W,06 03
3
R33 R125 R 35
142 41000 0087
IC,SPH E8281 D-216 PIN,L QFP-2 16,SU NPLU S
1
U2
12160 40005 12
RES,5K1Ω ,±5%,1/16W,060 3
2
R115 R116
123 80000 0018
2 4PIN, 0.5mm ,FPC SOCK ET SM T TYP E TOP
1
CN12
12160 40007 50
RES,75Ω ,±5%,1/16W,0603
1
R2
12160 40000 22
RES,2Ω2,±5%,1/16W,0603
2
R140 L30
143 01001 0355
P CB,SB ,DVD705E, 1.2mm ,107X 109m m(SUNPLUS )
1
12160 60003 30
RES,33Ω ,±5%,1/10W,0805
1
R160
121 60400 0223
R ES,22 KΩ,± 5%,1/ 16W,0 603
1
R135
12161 80001 03
RES,10KΩ ,4,± 5%, 1/16W,0603
1
RN1
121 60400 0562
R ES,5K6Ω,± 5%,1/ 16W,0 603
3
R12 R25 R129
12180 30001 00
CAP,10pF,±1% ,50V,NPO,0603
2
C1 C 42
121 80301 0272
C AP,27 00PF, ±5%,50V,X7 R,060 3
2
C16 C19
12180 30001 01
CAP,100pF,±5%,50V,NPO,0603
3
C4 C 5 C53
121 60400 0473
R ES,47 KΩ,± 5%,1/ 16W,0 603
1
R7
12180 30001 02
CAP,1nF,± 10% ,16V,X7R,0603
9
BC43 BC45 C72 C74 C7 5 C17 C20
121 60600 0000
R ES,0Ω ,±5% ,1/10 W,080 5
1
R39
BC14 BC10
142 22400 0023
Z ENER
1
D11
C54 BC44 BC18 B C15 C 67 C6 8
121 80300 0225
C AP,2.2 μF,+ 80%,-2 0%,1 6V,X7R,0603
2
BC38 BC22
BC1 BC2 B C3 BC 4 BC5 BC7 B C8 BC 13
144 84000 0018
D ECD, DL-C2 8D1(S HINWA)
1
BC52 BC16 BC17 BC19 BC20 BC21
143 82000 0147
F FC,12 PIN,1 .00mm ,160m m,
1
EC46
BC6 BC9 B C24 B C28 B C29 BC30 BC34
141 82705 0227
C AP,22 0μF,± 20%, 6.3X7 ,10V,-55℃--1 05℃
1
EC46
BC35 BC36 BC3 7 BC4 0 BC41 BC42
141 83002 0106
E .CAP, 10μF, ±20% ,4X5,1 6V,85 ℃
4
EC2 EC3 EC7 EC8
121 83002 0107
E .CAP, 100μF,±20 %,6.3X 5,16V,105℃
141 83004 0476
E .CAP, 47μF, ±20% ,5X5,1 0V,10 5℃
3
EC38 EC27 EC5
BC77 C43 C45 C4 8 C57 C76 C 77 C5 9
143 40500 0004
INFRAR ED RECEIV ER,IR 928-6 C
2
D12 D13
142 82000 0010
C RYSTAL,27 .000M Hz,±2 0ppm ,-30℃ ~+80℃ ,CL=1 8pF, 1
12180 30001 03
CAP,0.01μ F,±1 0%,50V,X7R,0603
12180 30201 04
CAP,0.1μ F,±10 %,25V,X7R,0603
6
53
C ONNE CT TY PE
DIO DE，5 V6，M INI M ELF
14
12180 00201 05
CAP,1μF,±10% ,16V,X7R,0603
5
C46 C58 C6 0 C61 BC33
12180 30102 21
CAP,220pF,±5%,25V,NPO,0603
2
C15 C18
12180 30001 52
EC1 EC4 EC6 EC32 EC36 EC37 EC40
EC41 EC42 EC43 EC44 EC53 EC 45 EC 22
XT1
H C-49/ US
CAP,1500pF,±10%,50V,X7R,0603
2
C6， C9
143 21000 0004
D ETEC T SW, SW11 0
1
K1
12180 30102 24
CAP,0.22μ F,±1 0%,25V,X7R,0603
1
C66
142 40000 0133
IC,CJ7 8L06,TO-92, CJ(V0 =6V IO M=0. 1A)
1
U8
12180 30103 01
CAP,300pF,±5%,50V,NPO,0603
1
C70
123 83000 0117
C MV70 0,2PIN ,PI=2 .0mm 135mm (SOCKET P IN)
1
CN9
12180 30003 30
CAP,33pF,±5% ,50V,NPO,0603
6
BC47 BC51 C79 C80 BC 49 BC 11
121 83000 0226
E .CAP, 22μF, ±20% ,4X5,1 6V,10 5℃
2
EC10 EC23
12180 30103 31
CAP,0603,330p ,16V,± 5%,NPO
1
C73
143 82000 0149
F FC,20 PIN,1 .0mm, 120mm ,E
1
CN7
12180 30004 70
CAP,47pF,±5% ,16V,NPO,0603
2
C47 C49
142 20600 0004
R EC D IODE ，1N4 001， 1A，1V ，50V ，DO －41
1
D7
12180 30004 72
CAP,4700pF,±10%,50V,X7R,0603
2
C2 C 3
12180 30004 73
CAP,0.04 7μF,± 10%,50V,X7R,060 3
1
C69
12180 30006 81
CAP,680pF,±10%,16V,X7R,0603
5
C62 C63 C6 4 C65 C52
7-1
MAIN BOARD
TABLE OF CONTENTS
Circuit Diagram ................................................................ 7-2
PCB Layout Top View ...................................................... 7-3
PCB Layout Bottom V iew ................................................ 7-4
Electrical Parts List ....................................... 7-5 to 7-6
7-1
7-2
CIRCUIT DIAGRAM
7-2
7-3
PCB LAYOUT TOP VIEW
7-3
7-4
PCB LAYOUT BOTTOM VIEW
7-4
7-5
7-5
ELECTRICAL PARTS LIST - MAIN BOARD
L ocatio n
Part NO.
Des criptio n
1
R 432
121604000 103
RE S,10KΩ,±5% ,1/16 W,060 3
RCF,100Ω ,±5%,1/8W
4
R 637 R403 R 405 R646
RCF,1KΩ,± 5%,1 /8W
9
R 526 R541 R 447 R510 R524 R5 42,R5 43,
Part N O.
Desc ription
12164 00001 00
RCF,10Ω,± 5%,1/8W
12164 00001 01
12164 00001 02
12164 00001 03
RCF,10KΩ ,±5% ,1/8W
QT Y
9
Q TY
Loca tion
R508 R511 R520 R412 R469 R 471-4 72 R4 45
24
R112 R636 R477 R480 R809 R 507 R 813 R 482
R433 R475 R635 R528 R530 R531 R 548 R 639
R 545,R 546
121604000 104
RE S,100K Ω,±5 %,1/1 6W,06 03
R 108 R408 R 470 R550 R802 R8 11 R4 73
121604000 123
RE S,12KΩ,±5% ,1/16 W,060 3
5
R446 R615 R618
R 429 R644
121604000 223
RE S,22KΩ,±5% ,1/16 W,060 3
3
R436 R551
R428 R442 R474 R640 R650
12164 00001 04
RCF,100KΩ ,±5%,1/8W
2
R 448-4 49
121604000 224
RE S,220K Ω,±5 %,1/1 6W,06 03
2
R512 R613 R616
12164 00002 24
RCF,220KΩ ,±5%,1/8W
4
R 534 R536 R 538-5 39
121604000 272
RE S,2K7 Ω,±5% ,1/16 W,060 3
3
R501 -502
12164 00002 72
RCF,2K7Ω ,±5% ,1/8W
1
R 503
121604000 394
RE S,390K Ω,±5 %,1/1 6W,06 03
2
R509
12164 00004 72
RCF,4K7Ω ,±5% ,1/8W
3
R 410 R424-4 25
121604000 472
RE S,4K7 Ω,±5% ,1/16 W,060 3
1
R444 R443 R476
12164 00004 73
RCF,47KΩ ,±5% ,1/8W
7
R 519 R423,Z D401, R527 R529 R532 R547
121604000 473
RE S,47KΩ,±5% ,1/16 W,060 3
3
R468 R810 R552 R628 R629 R621 R 624
12164 00002 20
RCF,22Ω,± 5%,1/8W
1
R 506
12164 00006 81
RCF,680Ω ,±5%,1/8W
1
R 804
121604000 474
RE S,470K Ω,±5 %,1/1 6W,06 03
12164 00007 52
RCF,7.5KΩ ,±5% ,1/8W
1
R 812
121604000 512
RE S,5K1 Ω,±5% ,1/16 W,060 3
1
R513
12165 00000 22
RCF,2Ω2,± 5%,2W
3
R 803,R 409,D 801
121604000 562
RE S,5K6 Ω,±5% ,1/16 W,060 3
1
R426 -427 R 603 R604
12164 00003 94
RCF,390KΩ ,±5%,1/8W
8
R 533,R 535,R 537,R549 R 515~R518
141604000 682
RE S,6.8K Ω,±5 %,1/1 6W,06 03
4
R601 R602 R614 R617
12164 80005 60
RCF,56Ω,± 5%,1W
1
R 805
121604000 752
RE S,7K5 Ω,±5% ,1/16 W,060 3
4
R620 R625 R627 R630
14220 30000 03
SW
11
D 417,D 422~ D423,D501 D 403 D 400 D 410
121604000 823
RE S,82KΩ,±5% ,1/16 W,060 3
4
R514
14220 60000 04
REC
14222 40000 09
ZENER
14222 40000 01
ZENER
14300 00300 88
PCB,MB,DVD703RS,,1.6mm,193.6 X151.7mm
11385 00000 39
DIODE，1N4148， DO－ 35
17
R451 ~454 R641 R643 R 631~R634
R710
D 405 D416 J 160 J1 46
121606000 000
RE S,0Ω,±5%,1 /10W, 0805
1
R421 R434 R114 C631 C633 R 700
1
U 802"1 "pin"4 "pin
121803000 101
CA P,100p F,±5% ,50V,NPO,0603
6
C603 -604 C 614-6 16 C6 20
DIODE， 3V3， 1/2W，DO－ 35
1
Z D402
121803000 102
CA P,1nF,±10% ,16V,X 7R,06 03
6
C415 C605 C606
DIODE， 10V， 1/2W，DO-35
1
Z D801
121803000 104
CA P,0.1μ F,+80 %,-20 %,50V,Y5V,0 603
3
C103 C403 C405 C408 C410 C412 C 414 C 418
21
C420 C508 C515 C613, C822 C617 C 802 C805
DIO DE，1N4001，1A， 1V，5 0V，DO－41
∮0.5mm,6mm
1
19
J 135,J 138,J1 49,J1 53,J17 4,J18 7,J191,J198 ,
C808 C826 ,C542 C540 C626
J 204,J 156,J2 02,J2 11,J21 2,J22 0,J227 ,,J22 5,
121803000 330
CA P,33pF,±5% ,50V,NPO,0603
J 234,J 231,J1 39
121803000 682
CA P,6800 pF,±1 0%,50V,X7R ,0603
2
C623 C627
C401 -402
11385 00000 41
∮0.5mm,7mm
6
J 136,J 192,J1 71,J2 28,J20 3,J20 5
121806000 105
CA P,0805 ,105,5 0V,Y5 V,+80 %-20%
2
C512
11385 00000 43
∮0.5mm,8mm
4
J 119,J 120,J1 34,J1 90
121806000 224
CA P,0.22 μF,+8 0%,-2 0%,16 v,Y5V, 0805
1
C501 -502
11385 00000 45
∮0.5mm,9mm
3
J 127,J 130,J2 30
121806000 225
CA P,2.2μ F,+80 %,-20 %,16V,X7R,0805
2
C513 C610 C612 C622 C607 C608 C 609 C 611
11385 00000 02
∮0.5mm,10mm
J 111,J112,J114,J12 1,J12 2,J125 ,J126 ,J140,
142245000 015
TR， DTC 343TK ，SOT －23
8
Q601
J 182,J 183,J1 84,J1 85,J186,J22 6 J196
142251000 001
TR， 2N39 04（NPN）， SOT －23
1
Q102 Q405 Q407 Q411 Q501 Q802 Q804 Q 507
15
11385 00000 04
∮0.5mm,11mm
7
J 103,J 104,J1 05,J116,J21 0,J21 5,J147
142245000 003
TR,2N390 6(PN P),SO T-23
8
Q401 -402 Q 404 Q 406 Q 408 Q 410
11385 00000 06
∮0.5mm,12mm
11
J 106,J 107,J1 24,J1 33,J15 1,J15 7,J167,J214 ,
142245000 024
TR， KTC8550S （PNP ），S OT-23
6
Q101
J 189,J 150,J1 58
142400000 416
IC,UTC45 58,SO P-8,U TC
1
U602 -604
11385 00000 08
∮0.5mm,13mm
5
J 154,J 155,J1 52,J1 01,J10 0
121803010 221
CA P,220p F,±5% ,25V,NPO,0603
3
C817 ~820
11385 00000 10
∮0.5mm,14mm
4
J 180,J 181,J1 61,J1 42
121803000 474
CA P,0.47 uF,±5 %,25V,NPO ,0603
4
C825
11385 00000 12
∮0.5mm,15mm
6
J 144,J 145,J1 95,J2 13,J20 1,J20 0
142245000 018
TR， KRC 102（ NPN），SOT －23
1
Q409
11385 00000 14
∮0.5mm,16mm
5
J 108,J 131,J1 32,J2 19,J12 8
121608000 102
RE S,1KΩ ,±5% ,1/4W,1206
1
R479
11385 00000 16
∮0.5mm,17mm
6
J 177,J 216,J2 29,J115,J12 3,J14 8
142400000 080
IC,AP150 7-5V,TO252 -5L,AN ACHI P
1
IC50 2
11385 00000 18
∮0.5mm,18mm
4
J 118,J 137,J2 18,J1 78
121845030 106
TAN .CAP,10μF,±20% ,10V, A
1
C413
11385 00000 22
∮0.5mm,20mm
1
J 221
121604000 470
RE S,47Ω ,±5% ,1/16W,0603
1
R648
11385 00000 23
∮0.5mm,21mm
6
J 109,J 110,J113,J141,J16 3,J21 7
121803000 123
CA P,0.01 2μF,± 20%,50V,X7 R,060 3
1
C624
11385 00000 26
∮0.5mm,23mm
1
J 168
142245000 021
TR， KRC 231S（ NPN），SO T-23
1
Q502 ~Q50 5
12164 40001 00
RCF,10Ω,± 5%,1/4W
1
R 113
141830000 105
E.C AP,1μ F,±20%,4X5,50V,105℃
4
C823
11385 00000 36
∮0.5mm,5.0mm
1
J 129
141830020 106
E.C AP,10 μF,± 20%,4 X5,16V,85℃
1
C106 C407 C806
14240 00003 86
IC,TDA7460N,SO 20,ST
1
U 501
121830020 107
E.C AP,10 0μF,± 20%, 6.3X5,16V,1 05℃
3
C101 C406 C509 C618- 619 C801 C8 04 C8 07
12160 40000 00
RES,0Ω,± 5%,1/16W,0603
5
R 407 R435 R 651 R652 R657
12160 40001 01
RES,100Ω ,±5% ,1/16W,0603
R 101-1 05 R4 01-40 2 R404 R406 R411 R413-419
121830000 225
E.C AP,2.2μF,± 20%,4 X5,50 V,105 ℃
R 422 R437 R 647 R504-505
141830000 475
E.C AP,4.7μF,± 20%,4 X5,16 V,105 ℃
5
10
22
13
C500 C621 C625 C628 C629
C813 -816 C 821
C503 ,C510 C504 -507 C514 C 519-5 21
12160 40001 02
RES,1KΩ,±5%,1/16W,0603
8
R 109 R638 R 645 R642 R521 R5 23 R5 25 R5 40
141830040 476
E.C AP,47 μF,± 20%,5 X5,10V,105℃
12160 60001 02
RES,1KΩ,±5%,1/10W,0805
1
R 801
121833010 227
E.C AP,22 0μF,± 20%, 8X7,16V,105 ℃
5
C700
12160 40001 03
RES,10KΩ ,±5%,1/16W,0603
R 508 R511 R520 R 412 R4 69 R4 71-47 2 R445
121842020 108
E.C AP,10 00μF,±20% ,8X16 ,10V,1 05℃
1
C541
121842030 338
E.C AP,33 00μF,±20% ,12.5X 25,16 V,85°
1
C827
24
R 112 R 636 R477 R 480 R8 09 R5 07 R8 13 R48 2
C417 C419 C511 C824 C632
7-6
7-6
ELECTRICAL PARTS LIST - MAIN BOARD
QT Y
L ocatio n
Part N O.
Desc ription
12184 20201 08
E.CAP,100 0μF,± 20%,8X16,1 0V,105℃
1
C 541
12184 20303 38
E.CAP,330 0μF,± 20%,12.5X2 5,16V,85°
1
C 827
12200 50000 19
STAND INDUCTOR,150 μH,± 10%,Φ0.3
1
R 500
14225 70000 01
TR,2SB1243TV2Q(PNP),ATV
2
Q 412 Q 801
14240 00002 18
IC,LM2950-5V,TO -92,HTC
1
U 801
14167 00001 09
GBX050,PTC(RILAIDA)
1
U 803*3 *pin a nd R8 07*1*p in
14240 00003 80
IC,TDA7386,FLEXIWATT25,ST
1
U 804
14282 00000 26
CRYSTAL,8.664MHz,± 30ppm,-20℃ ~+70℃,
1
X T401
CL=30pF,HC-49/US
14481 50000 22
TUNER,KST-C61 02LVD-100,FM/OIRT/AM
1
T UN10 1
12383 00100 86
CM700,20PIN,PWR/SPK EST-KNT-20-04
1
C ON80 1
12380 00000 23
2PIN,SOCKET 2.0mm DIP 180°
1
C ON70 0
12380 50000 95
6PIN,2.0mm,WAFER DIP 180°
1
C ON40 4
12380 50000 17
14PIN,2.0m m,WAFER 9 0°
1
C ON40 3
14220 60000 06
REC
14100 00003 19
CM226,BRACKET IC 7386,SECC,T0.8
1
12480 00000 25
FUSE,ZH270,15A,SLOW FUSE TYPE
1
14183 60004 77
E.CAP,470 μF,±20%,8X11,16V,105 ℃
1
C 803
12380 50001 02
7PIN,CONNECT,2.0mm,90°
1
C ON40 1
12200 50000 17
STAND INDUCTOR,68μ H,±1 0%,Φ0.4
1
L 503
14220 60000 08
REC
DIO DE，1N5822，3A， 0.9V， 40V， DO－ 27 1
D 504
14382 50001 90
CONNECTOR,20PIN,1 .0mm,
DIO DE，1N5401，3A， 1V，1 00V， DO－27 1
1
D 802
C ON40 2
CONNECTOR FZC6A-0 20
12300 00100 10
PCB,CB,CM206,94-V0 ,36×30×1.6mm
1
12183 00002 26
E.CAP,22μ F,±20%,4X5,16V,105℃
1
C 630
14224 80000 07
TR， S8050 （NPN ），TO-92
1
Q 602
12183 00101 07
100uF,±20 %,Φ5*11,16V,105℃
1
C 404
8-1
EXPLODED VIEW - MAIN UNIT
8-1
8-2
8-2
MECHANICAL PARTS LIST(BLACK PANEL, GREEN LIGHT)
Assembly Part N O
Desc ription
QT Y
I tem
1
84-D VD70 5RS-K B00-A
2
13-0 721-0 801-A
Fro nt-pa nel as s`y DV D705
1
Rim
1
3
14-1 074-2 610-0
Sc rewBT S M2. 6*10 B lack
4
13-0 343-0 001-B
Ca binet
5
14-1174-2 605-0
Sc rew BT S M2.6*5 Ni
6
14-0 721-0 004-0
7
8
I tem
Assembly Part N O
Desc ription
QT Y
51
13-0448-0 826-0
LE NS OF DVD 705
1
52
13-0148-0 821-0
PA NEL O F DVD 705
1
2
53
13-0548-0 804-0
Kn ob-SK IP/AM S CM 705
1
1
54
13-0548-0 808-0
KN OB LO UD/L OC/M ONO F OR C M705
1
18
55
13-0548-0 806-0
Kn ob-op en CM 705
1
Riv et pan el
2
56
14-0200-0 007-0
CM V100 ,SPRI NG RE LEASE NEW
1
14-0 318-0 011-0
Pa nel-bracket right
1
57
13-0548-0 807-0
Kn ob-ba nd CM 705
1
13-1121-0 004-0
Pu sh
1
58
14-0305-0 003-A
LC D CO VER F OR CM 110
1
9
14-0 221-0 002-0
Sp ring-e ject
1
59
11-2 602-0 030-0
LC D
1
10
14-1 055-2 005-0
Sc rew M 2*5
9
60
11-3 400-0 001-0
ZE BRA S TRIP FOR C M110
1
11
89-C AD31 0-016 6-0
Sk board
1
61
13-1048-0 001-0
Fi lter sheet for CM70 5
1
12
14-0 107-0 002-0
fel t
2
62
13-0900-0 002-A
Re flecto r lcd
1
13
13-0 821-0 001-0
Lo cker
1
63
13-0805-0 001-C
LC D hold er
1
14
14-0 221-0 003-0
Sp ring-lo cker
1
64
82-CM705 -KB02 -C
KB -ASS MBLY
1
15
14-0 721-0 002-0
Sh aft-loc ker
1
65
13-2321-0 001-0
E- WASH ER
2
16
89-C AD31 0-016 7-0
Fro nt-PC B ass `y
1
66
14-0221-0 004-0
l/R Rotation-sp ring
2
17
13-1 843-0 001-1
Du stproo f PVC plate
1
67
14-0721-0 005-0
Ri ght-sli de-blo ck-shi ft
1
18
14-1 254-2 004-0
Sc rew Pw M2*4 color Zn
5
68
13-1121-0 003-A
Ri ght-sli de-blo ck
1
19
13-1106-0 004-0
Da mper
1
69
14-0721-0 001-0
Sc rew FTP M2 *8
4
20
13-1121-0 001-0
Ge ar
1
70
13-0248-0 801-0
Pa nel ba ck for CM70 5
1
21
14-0 721-0 003-1
Riv et gea r
1
71
14-0721-0 001-0
Le ft-slid e-bloc k-shift
1
22
14-0 318-0 012-0
Bracket- gear
1
72
13-1121-0 002-A
Le ft-slid e-bloc k
1
23
13-0 521-0 715-1
Kn ob-eje ct
1
73
13-0800-0 008-0
BR ACKE T FOR LED OF CM V100
1
24
13-1 021-0 001-0
Le ns-gat e
1
74
13-0548-0 803-0
Kn ob-nu mber/ loud/b and CM705
1
25
14-0 318-0 009-0
Sid e stop per
2
75
13-0548-0 801-0
Kn ob-po wer CM 705
1
26
14-0 318-0 006-C
Fro nt U b racke t
1
76
13-0548-0 802-0
Kn ob-src /disp CM705
1
27
14-2 621-0 001-0
Mu t
2
77
13-0948-0 001-0
Lig ht-gu ide volume CM705
1
28
14-1170-3 008-0
Sc rew M 3*8
2
78
13-0748-0 501-0
Co smeti c-bar CM705
1
29
14-1151-2 608-0
Sc rew PAM2*8 Ni
2
79
13-0648-0 501-0
Kn ob-vo l for CM 705
1
30
14-0 343-0 006-0
De ck fron t brac ket
1
31
82-D VD70 5-SB0 1-A
Se rvo bo ard as s`y
1
32
11-3 501-0 014-A
SH INWA DVD DECK DL-C2 8D1
1
33
14-1 200-2 619-0
Piv ot screw M2 .6*19
2
34
14-0 538-0 001-0
To p-cove r
1
35
14-0 343-0 005-A
De ck rea r brac ket
1
36
14-1174-2 610-0
SC REW BTS26 10 NI
1
37
14-1 474-2 603-0
Sc rew M 2.6*3
2
38
14-1174-2 607-0
SC REW BTD26 07 MI
1
39
14-2 600-0 001-0
Po le
1
40
13-1 600-0 001-0
Ru bber
1
41
14-1174-2 614-0
Sc rew BT S M2.6*14 N i
2
42
14-0 618-0 001-0
Sh ort she et
1
43
11-2 501-0 002-0
An t sock et W/G ND L2 30mm
1
44
14-1174-2 621-0
Sc rew M 2.6*21
2
45
14-0 921-0 003-B
He at-sin k for CM700
1
46
14-0 331-0 001-C
Bracket- Back f or CAD 510
1
47
14-0 307-0 013-1
Bracket- IC7386
1
48
83-D VD70 3RS-M B01-A
Ma in boa rd ass `y
1
49
14-1 080-2 605-0
Sc rew M 2.6*5
2
50
13-1 721-0 001-0
Iso lator-sheet
1
8-3
8-3
MECHANICAL PARTS LIST(BLACK PANEL, RED LIGHT)
Assembly Part N O
Desc ription
QT Y
I tem
1
84-D VD70 5RS-K B02-A
2
13-0 721-0 801-A
1
Rim
1
3
14-1 074-2 610-0
4
13-0 343-0 001-B
Ca binet
5
14-1174-2 605-0
6
14-0 721-0 004-0
7
8
I tem
Assembly Part N O
Desc ription
QT Y
51
13-0448-0 826-0
LE NS OF DVD 705
1
52
13-0148-0 821-0
PA NEL O F DVD 705
1
2
53
13-0548-0 804-0
1
1
54
13-0548-0 808-0
KN OB LO UD/L OC/M ONO F OR C M705
1
18
55
13-0548-0 806-0
Kn ob-op en CM 705
1
Riv et pan el
2
56
14-0200-0 007-0
1
14-0 318-0 011-0
1
57
13-0548-0 807-0
Kn ob-ba nd CM 705
1
13-1121-0 004-0
Pu sh
1
58
14-0305-0 003-A
1
9
14-0 221-0 002-0
Sp ring-e ject
1
59
11-2 602-0 030-0
LC D
1
10
14-1 055-2 005-0
Sc rew M 2*5
9
60
11-3 400-0 001-0
1
11
89-C AD31 0-016 6-0
Sk board
1
61
13-1048-0 001-0
1
12
14-0 107-0 002-0
fel t
2
62
13-0900-0 002-A
Re flecto r lcd
1
13
13-0 821-0 001-0
Lo cker
1
63
13-0805-0 001-C
LC D hold er
1
14
14-0 221-0 003-0
Sp ring-lo cker
1
64
82-CM705 -KB00 -C
KB -ASS MBLY
1
15
14-0 721-0 002-0
Sh aft-loc ker
1
65
13-2321-0 001-0
E- WASH ER
2
16
89-C AD31 0-016 7-0
Fro nt-PC B ass `y
1
66
14-0221-0 004-0
2
17
13-1 843-0 001-1
1
67
14-0721-0 005-0
1
18
14-1 254-2 004-0
5
68
13-1121-0 003-A
1
19
13-1106-0 004-0
Da mper
1
69
14-0721-0 001-0
Sc rew FTP M2 *8
4
20
13-1121-0 001-0
Ge ar
1
70
13-0248-0 801-0
1
21
14-0 721-0 003-1
Riv et gea r
1
71
14-0721-0 001-0
1
22
14-0 318-0 012-0
Bracket- gear
1
72
13-1121-0 002-A
Le ft-slid e-bloc k
1
23
13-0 521-0 715-1
Kn ob-eje ct
1
73
13-0800-0 008-0
1
24
13-1 021-0 001-0
Le ns-gat e
1
74
13-0548-0 803-0
Kn ob-nu mber/ loud/b and CM705
1
25
14-0 318-0 009-0
Sid e stop per
2
75
13-0548-0 801-0
Kn ob-po wer CM 705
1
26
14-0 318-0 006-C
Fro nt U b racke t
1
76
13-0548-0 802-0
1
27
14-2 621-0 001-0
Mu t
2
77
13-0948-0 001-0
1
28
14-1170-3 008-0
Sc rew M 3*8
2
78
13-0748-0 501-0
1
29
14-1151-2 608-0
Sc rew PAM2*8 Ni
2
79
13-0648-0 501-0
1
30
14-0 343-0 006-0
1
31
82-D VD70 5-SB0 1-A
1
32
11-3 501-0 014-A
1
33
14-1 200-2 619-0
2
34
14-0 538-0 001-0
To p-cove r
1
35
14-0 343-0 005-A
1
36
14-1174-2 610-0
SC REW BTS26 10 NI
1
37
14-1 474-2 603-0
Sc rew M 2.6*3
2
38
14-1174-2 607-0
SC REW BTD26 07 MI
1
39
14-2 600-0 001-0
Po le
1
40
13-1 600-0 001-0
Ru bber
1
41
14-1174-2 614-0
2
42
14-0 618-0 001-0
Sh ort she et
1
43
11-2 501-0 002-0
1
44
14-1174-2 621-0
Sc rew M 2.6*21
2
45
14-0 921-0 003-B
1
46
14-0 331-0 001-C
1
47
14-0 307-0 013-1
Bracket- IC7386
1
48
83-D VD70 3RS-M B01-A
Ma in boa rd ass `y
1
49
14-1 080-2 605-0
Sc rew M 2.6*5
2
50
13-1 721-0 001-0
Iso lator-sheet
1
8-4
8-4
MECHANICAL PARTS LIST(SILVER PANEL, GREEN LIGHT)
Assembly Part N O
Desc ription
QT Y
I tem
1
84-D VD70 5RS-K B01-A
2
13-0 721-0 701-A
1
Rim
1
3
14-1 074-2 610-0
4
13-0 343-0 001-B
Ca binet
5
14-1174-2 605-0
6
14-0 721-0 004-0
7
8
I tem
Assembly Part N O
Desc ription
QT Y
51
13-0448-0 826-0
LE NS OF DVD 705
1
52
13-0148-0 721-0
PA NEL O F DVD 705RS 58C PROL OGY SILVE R
1
2
53
13-0548-0 704-0
1
1
54
13-0548-0 708-0
KN OB LO UD/L OC/M ONO F OR C M705 NO RD S
1
18
55
13-0548-0 706-0
Kn ob-op en CM 705
1
Riv et pan el
2
56
14-0200-0 007-0
1
14-0 318-0 011-0
1
57
13-0548-0 707-0
KN OB-NUMBE R/BAN D FO R CM7 05
1
13-1121-0 004-0
Pu sh
1
58
14-0305-0 003-A
1
9
14-0 221-0 002-0
Sp ring-e ject
1
59
11-2 602-0 030-0
LC D
1
10
14-1 055-2 005-0
Sc rew M 2*5
9
60
11-3 400-0 001-0
1
11
89-C AD31 0-016 6-0
Sk board
1
61
13-1048-0 001-0
1
12
14-0 107-0 002-0
fel t
2
62
13-0900-0 002-A
Re flecto r lcd
1
13
13-0 821-0 001-0
Lo cker
1
63
13-0805-0 001-C
LC D hold er
1
14
14-0 221-0 003-0
Sp ring-lo cker
1
64
82-CM705 -KB02 -C
KB -ASS MBLY
1
15
14-0 721-0 002-0
Sh aft-loc ker
1
65
13-2321-0 001-0
E- WASH ER
2
16
89-C AD31 0-016 7-0
Fro nt-PC B ass `y
1
66
14-0221-0 004-0
2
17
13-1 843-0 001-1
1
67
14-0721-0 005-0
1
18
14-1 254-2 004-0
5
68
13-1121-0 003-A
1
19
13-1106-0 004-0
Da mper
1
69
14-0721-0 001-0
Sc rew FTP M2 *8
4
20
13-1121-0 001-0
Ge ar
1
70
13-0248-0 801-0
1
21
14-0 721-0 003-1
Riv et gea r
1
71
14-0721-0 001-0
1
22
14-0 318-0 012-0
Bracket- gear
1
72
13-1121-0 002-A
Le ft-slid e-bloc k
1
23
13-0 521-0 715-1
Kn ob-eje ct
1
73
13-0800-0 008-0
1
24
13-1 021-0 001-0
Le ns-gat e
1
74
13-0548-0 703-0
KN OB-NUMBE R/MU TE FO R CM7 05
1
25
14-0 318-0 009-0
Sid e stop per
2
75
13-0548-0 701-0
Kn ob-po wer CM 705
1
26
14-0 318-0 006-C
Fro nt U b racke t
1
76
13-0548-0 702-0
1
27
14-2 621-0 001-0
Mu t
2
77
13-0948-0 001-0
1
28
14-1170-3 008-0
Sc rew M 3*8
2
78
13-0748-0 501-0
1
29
14-1151-2 608-0
Sc rew PAM2*8 Ni
2
79
13-0648-0 501-0
1
30
14-0 343-0 006-0
1
31
82-D VD70 5-SB0 1-A
1
32
11-3 501-0 014-A
1
33
14-1 200-2 619-0
2
34
14-0 538-0 001-0
To p-cove r
1
35
14-0 343-0 005-A
1
36
14-1174-2 610-0
SC REW BTS26 10 NI
1
37
14-1 474-2 603-0
Sc rew M 2.6*3
2
38
14-1174-2 607-0
SC REW BTD26 07 MI
1
39
14-2 600-0 001-0
Po le
1
40
13-1 600-0 001-0
Ru bber
1
41
14-1174-2 614-0
2
42
14-0 618-0 001-0
Sh ort she et
1
43
11-2 501-0 002-0
1
44
14-1174-2 621-0
Sc rew M 2.6*21
2
45
14-0 921-0 003-B
1
46
14-0 331-0 001-C
1
47
14-0 307-0 013-1
Bracket- IC7386
1
48
83-D VD70 3RS-M B01-A
Ma in boa rd ass `y
1
49
14-1 080-2 605-0
Sc rew M 2.6*5
2
50
13-1 721-0 001-0
Iso lator-sheet
1
8-5
8-5
MECHANICAL PARTS LIST(SILVER PANEL, RED LIGHT)
Assembly Part N O
Desc ription
QT Y
I tem
1
84-D VD70 5RS-K B03-A
2
13-0 721-0 701-A
1
Rim
1
3
14-1 074-2 610-0
4
13-0 343-0 001-B
Ca binet
5
14-1174-2 605-0
6
14-0 721-0 004-0
7
8
I tem
Assembly Part N O
Desc ription
QT Y
51
13-0448-0 826-0
LE NS OF DVD 705
1
52
13-0148-0 721-0
PA NEL O F DVD 705RS 58C PROL OGY SILVE R
1
2
53
13-0548-0 704-0
1
1
54
13-0548-0 708-0
KN OB LO UD/L OC/M ONO F OR C M705 NO RD S
1
18
55
13-0548-0 706-0
Kn ob-op en CM 705
1
Riv et pan el
2
56
14-0200-0 007-0
1
14-0 318-0 011-0
1
57
13-0548-0 707-0
KN OB-NUMBE R/BAN D FO R CM7 05
1
13-1121-0 004-0
Pu sh
1
58
14-0305-0 003-A
1
9
14-0 221-0 002-0
Sp ring-e ject
1
59
11-2 602-0 030-0
LC D
1
10
14-1 055-2 005-0
Sc rew M 2*5
9
60
11-3 400-0 001-0
1
11
89-C AD31 0-016 6-0
Sk board
1
61
13-1048-0 001-0
1
12
14-0 107-0 002-0
fel t
2
62
13-0900-0 002-A
Re flecto r lcd
1
13
13-0 821-0 001-0
Lo cker
1
63
13-0805-0 001-C
LC D hold er
1
14
14-0 221-0 003-0
Sp ring-lo cker
1
64
82-CM705 -KB00 -C
KB -ASS MBLY
1
15
14-0 721-0 002-0
Sh aft-loc ker
1
65
13-2321-0 001-0
E- WASH ER
2
16
89-C AD31 0-016 7-0
Fro nt-PC B ass `y
1
66
14-0221-0 004-0
2
17
13-1 843-0 001-1
1
67
14-0721-0 005-0
1
18
14-1 254-2 004-0
5
68
13-1121-0 003-A
1
19
13-1106-0 004-0
Da mper
1
69
14-0721-0 001-0
Sc rew FTP M2 *8
4
20
13-1121-0 001-0
Ge ar
1
70
13-0248-0 801-0
1
21
14-0 721-0 003-1
Riv et gea r
1
71
14-0721-0 001-0
1
22
14-0 318-0 012-0
Bracket- gear
1
72
13-1121-0 002-A
Le ft-slid e-bloc k
1
23
13-0 521-0 715-1
Kn ob-eje ct
1
73
13-0800-0 008-0
1
24
13-1 021-0 001-0
Le ns-gat e
1
74
13-0548-0 703-0
KN OB-NUMBE R/MU TE FO R CM7 05
1
25
14-0 318-0 009-0
Sid e stop per
2
75
13-0548-0 701-0
Kn ob-po wer CM 705
1
26
14-0 318-0 006-C
Fro nt U b racke t
1
76
13-0548-0 702-0
1
27
14-2 621-0 001-0
Mu t
2
77
13-0948-0 001-0
1
28
14-1170-3 008-0
Sc rew M 3*8
2
78
13-0748-0 501-0
1
29
14-1151-2 608-0
Sc rew PAM2*8 Ni
2
79
13-0648-0 501-0
1
30
14-0 343-0 006-0
1
31
82-D VD70 5-SB0 1-A
1
32
11-3 501-0 014-A
1
33
14-1 200-2 619-0
2
34
14-0 538-0 001-0
To p-cove r
1
35
14-0 343-0 005-A
1
36
14-1174-2 610-0
SC REW BTS26 10 NI
1
37
14-1 474-2 603-0
Sc rew M 2.6*3
2
38
14-1174-2 607-0
SC REW BTD26 07 MI
1
39
14-2 600-0 001-0
Po le
1
40
13-1 600-0 001-0
Ru bber
1
41
14-1174-2 614-0
2
42
14-0 618-0 001-0
Sh ort she et
1
43
11-2 501-0 002-0
1
44
14-1174-2 621-0
Sc rew M 2.6*21
2
45
14-0 921-0 003-B
1
46
14-0 331-0 001-C
1
47
14-0 307-0 013-1
Bracket- IC7386
1
48
83-D VD70 3RS-M B01-A
Ma in boa rd ass `y
1
49
14-1 080-2 605-0
Sc rew M 2.6*5
2
50
13-1 721-0 001-0
Iso lator-sheet
1

Car Audio DVD520

Transcription

Similar documents