GloKing Owners Manual.

i::i:r:r'::
I 'a. lit
'b.;.:,
t- 7't,.
'ii
t,
OUICK REFERENCE
SECTION
ts
1994-95
SAVE THESE INSTRUCNONS
Golden Glo'
Pellet Stoves
Lisud by EESPC (Energy and Environrnental Systems
Periormance Crcrporation) NVLAP lab code 03O1 fl3r lhe
irlbwin g applications.
Salety label shown in Quick Refererrce Section.
The P10C'F,
F/$F and Pt(X)-l
models are listed
icr residential and mobile horne use.
The PIOG! ins€n model is approved for masonary,
zero dearane and new onstruction applicaions.
r
Tested b UL9o7, UL1482,
05/), July 1993.
ASru
1509-93 (93-
urits utjlize pdletized wood br fuel and hav€ an
elecuical ratng of 115 VAC 60 HZ
AJI
Use of impoper fuel, chemical deaner, or impoper
etecrical sourcs may invalidaE he warranty.
P100 Free Standing Pellet
Stove l-irp
PloO Pellet Stove lnsart Line
SAFETY NOTICE
THE PURPOSE OF THIS I{ANUAL IS TO SUPPORT AND SUPPLEMENT THE SAFE AND
PROPER INSTALI-ATION OFTHE @LDEN GLO
Owner's Manual
PELLET STOVE SERIES.
PLEASE READ THIS EN'NRE fuIANUAL BEFORE
INSTALLATION AND USE OF THIS PELLET
FUEL.BURNING ROOM HEATER.
FAILURE TO FOLIOW THESE INSTRUCTIONS
COULD RESULT IN PROPERTY DAMAGE, BO}.
ILY INJURY OR EVEN DEATH.
ANY DEVIATION TO THESE INSTRUCT1ONS
I'AY INVAUDATE THE WARRANTY AND COULD
CAUSE SERIOUS CONSEQUENCES.
Pl oo-F
t-arge Free Standing Stove
Pl os'l
large FirePlacG lnsert
P75-F
llcdium Free Standing Stove
CONTACT LOCAL BUILDING OR FILE OFFICIALS ABOUT RESTRICTION AND INSTALLA.
T]ON INSPECTION REOUIREMEhITS IN YOUR
AREA.
l77O l-atrel Street
.
P.O. 8ox l7g . Florerr'e. Oregon 97439 r (503| 997'2666 o FAX (503f 997'A986
O1993, GloKing Stoves- All Rights Reserved.
lntroduction
Thank You.,.
...for purchasing a GloKing Pellet Stove. Welcome to the growing family of
environmentally conscience owners who enjoy the comfort of wood heat yet appreciate the
cleanliness and convenience of pellet technology. You should be applauded for your ecological
decision to utilize waste material by converting this renewable energy into clean and useful heat.
The Golden Glo Pellet stove has been designed and engineered to provide years of
safe and dependable service when operated, maintained and serviced as described in this manual.
All pellet stoves require some maintenance, however, we have strived to manufacture a user friendly
appliance that provides easy access to the clean out areas. With your reasonable and prudent care,
the GloKing stove will deliver years of remarkable clean buming efficiency.
'
This owner's Manual has been carefully written and contains valuable information
necessary for a safe and successful installation. The Table of Contents is designed to provide an
easy reference to the topic desired. Each topic is intended to be an entity in itself with additional
information that presents a more complete understanding about the subjecrt. We urge you to read
this manualcarefully before starting the actual installation work.
To validate your warranty, complete the registration form on the back page and mail
within 10 days of purchase. We recommend you retain your bill of sale and record the model, serial
number, purchase date and where purchased below.
IMPORTANT INFORMATION
The following data may be needed to accurately respond to service inquiries:
From the Safety Label:
Model:
Serial Number:
Date of Manufacture:
From the Bilt of Sate:
Purchase Date:
Purchased From:
Please attach your bill of sale to this page.
PROTECT YOUR ASSET.
Itlail in the urarranty registration form on the back page within 1O days of purchase.
We wish you many happy years of heating with your new
GloKing pellet stove.
AmericaS getting the Glcr
Golden Glo Model PlOO-F Large Free Standing Pellet Stove
E-
Table of Specifications
32"
24"
22"
282 tb.
3"
45 tb.
Heioht
\/Vidth
T
Itenth
Weioht (lb.
Chimnev Size
Hoooer Cooociiv
BTU 0utout
Approx. Pellet
lnout Usooe
-
5 673 37.024
.9 to 5.5 lbs per
hour
-zlt'
+
PlE'?ltrElflfl
00-F sidewall / Bad$ilall clearances
Minimum Clearances
--P1
Americat getting the Gld'
Quick Reference
Golden Glo Moder p1o0-l Large Fireplace lnsert
Table of Specifications
_
T
I
I
I
I
f
EpgtJtTFOfiT
i ll+
I
rt
/4"
1? 1 /4"
22
g..AnllEI
Fa+-tf
#*ffiffi
F-----rtii!Fntilc^inr
IET'E
- Side
1
14"
Weiohi
1l'f
r
width
Heiqht (on heorth)
[xtensions onto Heorih
Deoth into Fireoloce
T
282
lbs
Chimnev Size
Reoulor Hoooer
[xtended Hopper
BTU Outout
Approx. Pellet
5.673
37.024
.9 to 5.5 lbs per
lnput Usooe
hour
3"
42 lbs
60 lbs
-
REGUI.AR STfrOUD COVERS MAXMUM 4A'W X 3?H
FIREPLACE OPEMNG
I
I
I
I
I
I
crRcljIT
XTAND
COI'EF
I
I
21 1t1'
TAFGE SHRCtt D CO/EAS MA)OMuM .[8. X
SIIAII $tRq,JD CO\€RS titAxfir,trM 4{r X ZE.
f
22t
00-l- From Vi€w
MtN ___-_j,t
P10&l- lnsort - Bick View
__N 4. t{F
to
Q-2
AmericaS gening the G,d,
I
I
Golden Glo Model PZS-F Medium Free Standing Pellet Stove
+
t-
Table of Specifications
29"
77"
??"
Heiohi
\/vidth
Deoth
Weioht (lb
A.
'
unrmnev 5t7e
Honoer Conocitv
BTU Cuiout
Approx. Pellei
ts'
241
nt
tb
J"
JJ tb.
5.225 24.185
7q
-
.8 io J.6
lnout Usooe
lbs per
hour
- Side Vi€w
2'
+l
E'+
''/\
) ''..:
._P753o"wlDEMlulMUx+
/ Backwall
Q-3
America3 getting the Gld"
I
Quick Reference
T
Quick Reference
E
This section is included only for a quick reference
to the operation of your Golden Glo Pellet Stove.
Please read this entire manual before installation
and use of this pellet fuel buming room heater.
J
DO'S:
I
GASOLINE.WPE LANTERN FUEL,
KEBOSENE, CHARCOAL LIGHTER
FLUID, OR SIMILAR LIQUIDS TO
'FRESHEN UP' A FIRE IN THIS
HEATER. KEEP ALL SUCH LIQUIDS
WELL AWAY FROM THE HEATER
WHILE IT IS IN USE.
Oo comply with federal, state and local
codes.
I
fI
J
Oo obtain a permit, if required in your area,
to ensure a safe and legal installation.
Oo check with a reputable and licensed contractor when having your stove and chimney
installed.
oo
instalt vent at clearances specitied by
the vent manufacturer.
ueven usE cAsoLrNE,
J
ceurtoN: MovrNc
PARTI MAY
CAUSE INJURY. DA NOT OPERATE
UNIT WITH THE SIDE PANELS
REMOVED.
DON'TS: SAFETYPRECAUTTONS
J ooworrrvsrALL A FLUE DAMIER
IN THE EXHAUST VENTING SYSTEM
OF THIS UNIT.
D
SHOCK. DISCONNECT POWER
BEFORE SERVICING UNIT.
tr rrus srovE ts Hor wHEN
OPERATING. CARE IS REQUIRED
TO AVOID SERIOUS BURNS.
J oo Nor coNNEcr rHts uNrr ro A
CHIMNEY FLUE SERVING ANOTHER
APPLIANCE.
D ron
uMTs To BE TNyTALLED tN
MANUFACTURED HOtttES; DO NAT
INSTALL IN SLEEP'NG ROOM.
CAUTTON : TH E STRUCTU RAL
INTEGRIry OF THE
MANUFACTUNED HOME FLOOR,
WALL, AND CEILING/ROOF TilUST
BE MAINTAINED.
oattoER: RrsK oF ELECTRT,AL
PRE.START CHECKLIST
f]
use rHE scRAPER TooL PRovtDED To
SCRAPE THE HEAT EXCHANGER
TUBES
I cuaN THE Two BAFFLEs uP uNDER
THE HEAT TUBES
f] cleeN THE coMBUsnoN cHAMBER
f cleaN HREPoT
f] cuaN DooR AND GLAss
I cnecK HoPPER
r-.I CTTCCK OVERALL CONDITION
Q-4
America3 gening the Glcf
n
START.UP PROCEDURES:
f]
n
n
fl
I
n
r
STAHTING ITISTR UCTIONS
fottow pre.start checkffst.
ptace thermostat ON-OFF sllder switch
to
the desired mode.
fitt burn pot one half to three quarters tuil
with pellets.
Apply an adequde but reasonable amount
of approved fire-starter (gelled alcohol type
prefened) on pellets, then put a few more
pellets on top of the firestarter.
Turn ON-OFF switch to "ON..
turn heat control switch to the desired setting. NOTE: For best resufts, set to medium
until pellets are feeding and the convection
blower comes on.
lgnite pellets.
Close door.
---"+o al
"-ffiqrun.."
S#
[I
fJ
fl
press the "Acilvate pellets- (Start) button
(the green light indicating a ready condition
should come on but pellets will not start feeding untilthe proper operating temperature is
achieved which will be disptayed by the pulsating yellow light). NOTE: lt may take 10-1S
minutes for pellets to start feeding.
Set fine-tune adlustrnents (flame and circulating fan) for desired performance.
ff unit doesn't start: review owners manual,
instructions and retry procedures.
SHUT OFF INSTRUCNONS
turn ON-OFF switch to "OFF-.
fJ fne
auger will stop feeding peltets but
both blowers will continue to operate until
the unit has achieved the proper cool down
status. This may take 30-90 minutes for both
blowers to stop.
Consumer Control:
o+-
oPERAru,
1. On/Off
2. Manual Feed Option
3. Heat Selection
4. Start (press lnitialize button)
5. Red light turns green to indicate
ready
6. Auger motor operating Amber light
comes on (light comes on onty when
auger feeds)
_l
7. Fine Tune Flame (for variations in
fuel, chimney resistance & line vottage)
8. Fine Tune Fan (personal choice)
9. Thermostat Selection
NOTE: See electrical and operating section for complete details.
America3 gening the Glo'
#h
,
Quick Reference
SAFTEY LABEL
CONTACT YOUR LOCAL BUILDING OR FIBE OFFICIAI-S AEOUT
RESTRICT]ONS AND INSTALLATION INSPECTION IN YOUR AREA
Uclad llaronry/Factory Eullt Flreplace lnseruB uilt-in Fir€placo
Room H..t r, Pcllot Fuel Buming Typc
Abo lor Urc ln Mobllc Homer
llanuteclurcd by
ItttcY lto
arvraorrttt^!
tYatl!a rlrrolt^tol
ootroa^llor
GLO KING STOVES
P.O.
Bor 179
Flonncr OR 97439
Kent WA 98032
NVLAP I.AB COOE O3O1
'PREVEIIIT HOUSE RRES'
lnrtall and urr only ln accordancc
wlth m.nuttcturor'r lnrtallatlon
lnrtructlonf and your local bulldlng
coder
CAUTION: Spcclal mcthodr sr.
requlrcd when pr..lng chlmney
through a wall or calllng, ref6r to local
buildlng code.. Do not conncct thit
unlt to a chlmney ftue rervlng anothor
appllanco.
WARNING: (IIOBILE HOME) An
outsld. alr lnlet mu3t bo provldod for
combustlon and bc unnestrlct d whll€
unlt ls ln u!o. Do not install appllanco
ln a sleeplng room. The structural
integrlty of thc mobilc homc floor,
walls and celllng/roof must bc
Serial No.
Modet: flnroor flez+r
fle ro+r !ezsl
TestedTo: UL9O7,ASTM1509gt
Test Date: July,1993
ReportNo. 93-055,93-057
Type Ol Fuel: PelletLed Wood
Electrlcal Ratlng: 115
DANGER: Rlsk
VAC
50 Hz
ol electrical shock.
Dlsconnect power bafore servlclng
unit, Do not routo power cord beneath
maintained.
NOTE: Reptace glass only with 5mm
caramic.
heat6r.
For built-ln appllcatlons s6€ lnstal-
Components Requir€d tor Mobile
lation manual.
Components Required for Residentlal
lnstallatlon: Listed Petlet VenL
Home lnstallation: outside Air KiL
lnsert Clearance Diagam (P 100-l,P 791) lnstall insert with a minimum of B.
clearance to combustible sidewall, 4'
to side and 4' to top trim, 15' from
top ot lnsert to mant€I. Floor protector
must be 3/8' minimum noncombustible material or equivaient,
extending 6' in front ot insert and 4'
to both sides. When used as an insert
stove, install only in a magonry
flreplaco, built to UBC Chapter 37 or a
llsted lactory bullt (zero clearancc)
flreplace. Do not rcmovo brick or
mortar from masonry flreplace to
accommodate lnlort. U8o tlu6 outlat
J
J
3
rll
o
6
with an approved pellet llner.
Mlnimum Clearancet to Combugtjble Matoriala (ln inches).
Fro.rtandlng Clearanca Dlagram (P 1O&F,P 75-F)
-
ucrrr&
Aa
cdturl
R@srFEcm
EMW: ffi
Floor protector mutt br
3/8' minlmum thlcknaaa
non-combustlblc -met rlsl
or equivalent, artendlng
beneath hoatar and to th.
fronUsides/rear as indl.
catad.
P 100-F ALCOVE SPECIRCAIONS:50' mlnlmum height, 44' minlmum widtlt
32'marlmum dcpth.
P 75+ ALCOVE SPECIFICATIONS:
32'marlmum depth.
60' mlnimum helght, 42' mintmum wldth,
Datr ol Manulactura
1993 1994 1995 Jan. Fcb. Mrr. Apr. May Juno July Aug. S€pr. Cct. Nov.Doc.
nntrtrntrtrxtrnxrrrn
LABEL
DO NOT REMOVE THIS
Q-6
Made
in
U.S.A.
Americas gecing the Glo"
F
[l
J
FtHFFEi6
z
-+*
<f)
.l)
u.l
z
o-XTE
l--.
ul<
J-
=g
-*
-cc
E
U
(l
==
HF
cll!
o
tIJ
3
8
et
-otr
a
o
E
o
E6s
f<>
co
I(J
L
(J
66d
4
=
I
o
r
2
o
()
U)
G
o
=
@
F
@
=
I
+
a
d
F
a
=
o
o
=
(l
xo
t3-
F
Uu I
o
o
2 E c G!+ A a (5 *. o
F F
F
o
3EH
o
JXU E !o o 6= o
G l
(.5 U
F 6
2 OYE ql u =
e
c
d = c E
6
=
o
(
,
d
= Htg 4 6
o E95 =
F =
o E
EF
?
gsE Eo 4(5 u3
I!
6
F tE
6
ts
u
u
.
:
-
t
Eg =
o
2
!
o
ut
t
6
lF aa
=
E
6
2
ts
AQ
occ
t1
l=
I
zo
;d
o
I
I
I
q
L
H
E
a
u
a
z
a
6
H
&
('
CT
o
F
-tE
o
u
=
E
HI gF E3 u F
o
z
cc=
=tt)
Z.L
=P
O6
ilH
gH
5
l!
I
It
I
I3
x
5
6
5
ffi5
!
?*
e
g
IJJ
(t
?'
I
otsH HrlM
-
3llHM
-
-
-
-
I
I
E
F
6
6
U
E
u
=
h
5
I
I
9cr
t-4.
I
e59
690
6d
o
Y1
al
ul
I
*8; i
J>l.
=dn
6l#
I
I>-
I
i
E
o
z
e
-
-
t
ul
a2
t
I
H
E
al =i
oFt
ul
I
I
€
3
N:l3Ue HI|M 3IlH,1
6:
*;8
'fi=:3F
f
I
v_
=;^L=ut
=FbEF
=
*
A- - no-n:rr'
-7!(ffi--r
U\
B-H?3
-
Eli 6
Ig
b76
F
]ut
I-
su
PH
5
H9
u
t=
cc
:iF
)J
s'I
'
6
3CNVAO FUIA tsIlH/vl
$Nrd NMoHs) 3rlHrv\
-an
Yo
^<
E6
8v,
occ
of;
*'l
EHf; !o
uJ >O
>r
F
3
-
-
cr
o
N!l:lu9
-
-
-
u)rE{
6+0 * /6 cz
Trim Pot Locations
(Rcverse Board Side Perspcctive)
Altitude Adjustment
Circulating Fan Adjust.
Flame Adjust
Adjusts Combustion
Fan to 65 Volts on low
Heat Control
ebm /
Mclran
shunt
Cycle Time Adjust.
Min. on Time Adjust.
lnw
Fuel Adjust.
Fuse
AdjustsConvection
Fan to 57 Volts
On / OffSwitch
eflU+
=Facing direction forthe trim pot.
SERVICE GUIDE
GOLDEN GLO CIRCUIT BOARD
CONTROL PANEL OPERATING
FEATURES
FUSE FOR SAFETY
A 3 amp fuse is used to protect the
user from an electrical malfunction. The P 100
and P 75 model stoves are quite economical to
operate since they only use 177 watts of power
at the maximum burn rate.
P100 and P75 Series Control Board
A. Start Button
B. LED Light
Yellow Pulsating - Auger rotating
senses manualfeed activatiion as
wellas timing circuit on time.
INITIALIZE
--+Q
(READ\I
GREEN
(NEEDSATTENTTON)
a*
Itti\
-t
(sTAnT)
FESET)
d:r.:.:::::.r.r.:.:::::.:i:::.l\
t::::t:t::l::i:':.:.:t:t:i:t:i:/
\nj
C. Fine Tune Adjustment of Convection Blower from predeterminded setting.
-\_-/
D. Oblong Mounting Holes to allevi-
FINE
TUNE
FI.AME
ADJUSTUENT
c
ate stress on board due to alignment of screw holes.
E. Rocker Switch (on/off)
F. Manual Feed: spring loaded and.
must be held to dispense pellets.
G. Fine Tune Adjustment of Com-
bustion Air +/- 5% of predetermined voltage to exhaust or combustion blower.
H. Gombination (green/red) LED
Light:
HEAT CONTROL
'@
MANUAL FEED
RED: (Power is on, but needs
user attention)
GR EEN: (Ready) indicates power
available to auger.
Consumer Control:
1. On/Olf
2. Manual Feed Option
3. Heat Selection
4. Start (press lnitialize button)
5. Fine Tune Flame (for variations in
Dealer (lnstaller) Adiustments on Back of Circuit Board:
Thermostat Option: 2 connecting screws and on/off slider switch
Low Feed Rate Adjustment: Low setting only approximately .B-1.75 tb/hr.
Altitude Setting: Predetermined compensating voltage to combustion air
blower 0-10 thousand feet indicator.
fuel, chimney resistance & line
voltage)
6. Fine Tune Fan (personal choice)
7. Select thermostat option
America3 getting the Gld'
SERVICE GUIDE
COMBUSTION & CONVECTION
BLOWER CONCEPT DIAGRAM
ON / OFF SWITCH
140" F
130" F
BY.PASS THERMODISK
TRrM POT (BACK OF BOARD)
ALTITUDE INITIAL SETTING
O-10 THOUSAND FEET
FLAME ADJUSTMENT
FINE TUNE (FRONT) KNOB
ADJUSTMENT FOR LEAN
TO RICH SETTING
FrNE TUNE (FRON'I)
CIRCULATING FAN
CONTROL !5VOLTS
r 5 voLTs
EACH SETTING HAS
PREDETERMINED VOLTAGE
"GANG CONTROL"
,./
\
\
COMBUSTION
(EXHAUST)
BLOWER
\
I
VARIABLE
SPEED
3-POLE:
AUGER MOTOR ON ]]ME
COMBUSTION BLOWER
CONVECTION BLOWER
4-POSITION HEAT CONTROL:
LOW
MEDIUM
HIGH
MAXIMUM
CONVECTION
BLOWER
185 CFM
PSC
PSC means PERMANENT SPLIT CAPACITOR motor (very efficient).
LOW LIMIT SWITCH 1 THERMODISK keeps both the combustion (exhaust) blower and
convection blower on (until cool down) wneri Off switch is activatecj.
LOW LIMIT SWITCH 2 THERMODISK does not allow convection blower to come on until
operating temperature is achieved. Also shuts down first on shutdown. Blower will not come on
after electricity loss & back on.
FINE TUNE ADJUSTMENTS: prederermined altowabte range.
FLAME ADJUSTMENT: allows consumer to vary the combustion blower to compensate for
chimney configuration restrictions, variations in fdel moisture and/or density, plus'line voltage
changes.
CIRCULATING FAN ADJUSTMENT allows consumer to iine tune ihe convection lan for
dosired speed.
America3 getting the Gld'
SERVICE GUIDE
-
FUEL SYSTEM CONCEPT DIAGRAM
INITIALIZE
(START.o.
OFF
SWTCH
ON /
TRESET) LOW LtMtT
SWITCH
PRESSURE HOLD
MANUAL FEED
(BY-PASSES
SAFETY DEVTCES)
THERMODISK
NORMALLY CLOSED
HIGH LIMIT THERMODISK DETECTS
OVERFIRE OF CONVECTION BLOWER
MALFUNCTION:
230'F(Pl00F, P75F)
PROOF OF FIRE, 110"F
NORMALLY OPEN
190'F(P100t)
Green-Ready (when switch closed)
Red-Needs Attention
(RED LED LIGHT COMES ON WHEN
HIGH LtMrT SWTTCH OPENS)
120V
AC
VERIFIES: EXHAUST BLOWER ON
(NEGATIVE PRESSURE)
VERIFIES: CHIMNEY FREE OF
OBSTRUCTIONS
\
(RED LED LTGHT COMES ON WHEN
vAcuuM swlTcH oPENs)
PRECISION SPEClF!CATIONS
SECOND
4-SECOND DUTY CYCLE
1 RPMGEAR MOTOR
!.1
2.25" DIAMETER
1.75" PrTCH (Pl00)
1.s" P|TCH (P7s)
LOW FEED RATE
ADJUSTABLE ON
TrME (.75.1.s
sEcoNDS)
ON
THERMOSTAT
m
i'riiieH-siriii'cH
(FRONT) oFF
OFF
ON
(BAcK)
ON
eo
scREws
CIRCUIT BOARD
6.SECOND DELAY CIRCUIT TO BY.PASS
SHORT-TERM ELECTRICAL OUTAGES
OR INTERRUPTIONS
l*.
"r"-l<-4
sEc-+|.-.
"."--'l
DUTY CYCLE
INITIALIZE (START or RESET) BUTTON: Normally closed (after activalion);open (red LED light on)
when high limit switch opens or vacuum switch opens. Red light also on when slove is in by-pass
mode.
Note:
Pellets will not be dispensed until all safety conditions are met and the consumer resets the
INITIALIZE (START or RESET) button (green LED light).
All safety devices are wired in series (and logic). All correct conditions must be met belore pellets can
be dispensed. lnstant shutdown (no pellets fed) occurs il any adverse condition is detected.
America3 getting the Gld-
DiAffiffi
ot'i/oFFswlTcH
TRH{ POT iBACK OF BOARD)
ALT{TUDE INITIAL SETTI}{G
CF10 THOUSAND FEET
FLAI.IE AN'USTMENT
L
(
FrNE TUNE (FROI{T) KNOB
AqJUSTI,{ENT FOR LEAN
F
oro+I5volrs
+On-sVOLTS
FRor"i PRESET voLTAGES
TO RICH SETTING
r 5 VOLTS
EACH SETTING HAS
PSC nreans PERMANENT SPLTT CAPACITOH moior (very efiicient).
LOW L:iClT SV/lTCll 1 THERMOBISK keeps both the oombustion (exhaust) blowe: arld convection
biower on (until cooi down) when OFF ttv;16i-t is aciivated.
FINE TUNE AD.,USTMENTS: predetermined allowable range,
FLAME ADJUSTMENI: allows @nsumer to vary the combustio:r blower to
compensate for cfrimney configuration restrictioris, variations in iuel moisture
and/or density, plus line voltage changes.
d
I
I U,TY+
,;-4o*
ig
SI*f{[ ,fr.
America's getting the Gl CT
I770 Laurel Street
. P.O. Box 179 '
Florence, OR97439
I
I
I
I
CONVre]fl@N BL@WGR CO, ric €P,r D NAG&.A-,}l
ON/OFF SWITCH
CONVECTION BLOWER
THERMODISK
LOW LIMIT
swlTcfl
2
t/10" F
130'F
BY.PASS THERMODISK
FisE TUNE (EBO|{I)
CIRCULATING FAI{
CONTROL T5VOLTS
HEAT
CONTROL
FACH SETTING HAS
PREDETEFMINED VOLTAGE
'GANG CONTROL'
+----APPROX'I'ATE VOLTAGE PlCO & P75
65
57
MED
75
bo
HIGH
85
7g
IriAx
L!NE
L!NE
,\
LOW
McCLEAN ebm
LOW
SPEED
3.POLE:
. AUGER lilOTOR ON TIME
COI,{BUSTION BLOWER
CONVECTICN ELOWER
4-POSiTICN H EAT CGNTROL:
L'IIIE VOLTAGE AT 115 VOLTS
FAN ADJUSTMENT AT 12 O' CLOCK POSITION
I
VARIASLE .
MEDIUfiN
\
BLOWFR I
CONVFCTICN
HIGH
MAXiMUM
,/\/
\
185 CFM
PSC
PSC means PERMAI{ENT SPLIT CAPACITOR rnoior (very eificient).
LOW LlttJlT SWITCH 1 THER,TjODISK keeps both the combustion (exhaust) blower and
convection blower on (until cool down) when OFF switch is activated.
LOW LIMIT S$JITCH 2 THERMODISK does not allow convection blo'.ver to corne on uniii
operating temperature is achieved. Also shuts down first on shutdown. Blower will not come on
after eiectricity loss & back on.
FINE TUNE ADJUSTIIENTS: predetermined allowable range.
CIRCULATING FAN ADJUSTMENT: allows consumer to fine tune the convection fan for
desired speed.
"
-'
,.,.,
H,3#l*i{ii:q
Gld''
A-merica's getting the
lTT0Laurelstreet.
P.O.
8ox
179
.
Flcrence, OR 97439
.
5031997-2666. FM 5031997-8986 i
-**-**--_---.--J
11i94
f-
tI
I
INMALEE
(smlL91!f,srD LowuMrr
ON/OFF SwlTC tt
PRESSURE
HOLD
SHTCH
THEHMODTSK
NORMALLY CLOSED
HIGH LIMIT THERMOO'SK DETECTS
OVERFIRE OR CONVECTION
ELOWER MALFUNCTION:
230" F (P1C0 F, P75 D
1eo" F {P100 D
MANUALFEED
{BY-PASSES
SAFETY
t
LED:
DEVTCgS)
PROOF OF FIRE, 11fF
NORMALLY OPEN
/
Gr+en--{leady (when switch closed)
F e<i-l.leeds Attention
(c5D LED LIGHT COMES ON V/HEN
HrcH LrMtT SWTCH OPENS)
VEFIFIES: EXHAUST BLOWEH ON
(NEGATTVE PRESSURE)
VERIFIES: CHIMNEY FREE OF
t20v
ccMBUST|ON
CHAMB€R
VACUUM
SY/ITCH
OBSTRUCTlCNS
AC
ltti
l
TI
{::!
LED LrcHT COMES O_I|_WHEN
vAcuuM swrTcH opENs)
INITIALIZE (STAfrT or RESET) BUTTCN: Normaily closad (after activation); cpen (red LED tight on)
when high limit switch opens or vacuum switch opens. Red light also on '"vhen stove is in by-oass rnode.
Note: Pellets lvill not be dispensed until all safety conditions are rnet and ihe ccnsumer resets the
INITIALIZE (START or RESFI) button (green LED !ight).
All safety devices ara wired in series (and logic). All corract conditions rnust be met before pellets can be
dispensed. lnstant shuidcwn (no pellets fed) occurs if any adverse conciition is Cetected.
-r*-'-2#!s;{i f,#
America' s getting the
10194
Gld'J
lTT0LaurelSrreer. P.O. Box 179
t
Florence,CR97439
t
5031997-2666. FAX 503/997-g9S6
I
$vstsAQ@-h{gge{'
INITIALIZE
{START or RESEI)
I
ON/OFF
I
I
I
PRESSURE
HOLD
MAHUAL FEED
(BY-PASSES
SAFETY
I
I
SWTCH
SWTCH
I
DEVTCES)
e"
LOW LIMIT
THERMODISK
AUGER TII,III-IG
ON T]ME
6\
t\,
Y
l=b,
/\,.\
120V
PROOF OF F|RE, 110"F
NOFMALLYOPEN
Gree*-Flea{ {when switch closed)
fed--lleeds Attention
P100
P75
CYCLE
oN TIME (SEC)
1.75"
PITCH
1.125"
PITCH
.u
.77
LOWEST LOWEST
MEDIUM
1.15
2.51
1.72
VERIFIES: EXHAUST BLOIYER ON
HIGH
{NEGATTVE PfrESSURE)
3.10
2.17
2.50
5.46
5.30
OBSTHUCTIONS
\/
4 SEC DUTY
LOW
.75 - 1.s
VERIFIES: CHIMN€Y FEEE OF
AC
POUNDS
PER HOUR
MAXIMUM
4.00
{cor.rTrNUor.is
FEED)
HEAT
coMrRcL J h?g,r*
1I iiieti-"'
sELEcnoN s!,ylTcH
1 RPM GEAR MOTOR
M.qxtilul,r
PRECISION SPECIFICATIONS
SECOND
4.SECOND DUTY CYCLE
I.JtOTOR
r.1
T-
'ffi
,@
AUGFH
2.25" DlAtnETER
I
LOW FEED R,{TE
ATUUSTABLE ON
T]ME
LOW.7s SEC
HIGH 1.5 SEC
t.75"
OFF
THERMOSTAT
s'ir6iii-sirviibx
(FBoNr)
PTTCH (P100)
1.125' ptTcl{
f
OFF
CN
CN
OFF
ON
{P75)
CFF
(BACK)
O
O
SCREWS
CIRCUIT BOARD
SSECOND DELAY CIRCUIT TO BY-PASS
SHORT.TERM ELECTHICAL OUTAGES
OR INTERRUPTIONS
rtll
j+-- *4 o="--js_
SEC -->i<- {
4 irLv
SEC---rl<- *4 o=t_-l
SEC ---;
-r-
l-
DUTY CYCLE
INITIALIZE (START or BESET) BUfiON: Normally closed (after activation); open (red LED tight on)
when high limit switch opens or vacuum switch opens. Red light also on when stove is in by-pass mode.
Note: Pellets will not be dispensed until all safety conditions are met and the consurner resets the
INITIALIZE (START or RESFI) button (green LED light).
All safety devices are wired in series (and logic). All conect conditions must be met before pellets can be
dispensed. lnstant shutdown (no pellets fed) occurs if any adverse condition is Cetected.
'J
j
I
1
t4-'l', #l*l{!it#'
gening the
0/94
4Igii"
s
Gldt'
177o Laurelsl'eet
.
P.o. 8ox 179
. Florence,
CR 97439
.
5o3/997-2666
.
F.{X so3/gg7-8g86
Analog logic, on-off auger rotation, duty cycle {fixed)
4-sec duty cycle, I revolution per minute (RPM) Sear motor
"On Time" indicated by yellow LED light
VOLTS
r
20v
AC
tl'l
+- ouw
i
CYCLE
* |*
4
sEC --'i *
4
sEC ->
sEc
i
DUTY CYCLE means start of On Time until start of next On Time
LOW: "vatiable" (adjustable) on time for low feed rate only
A
.7s
1.s
sEC
Low feed rate On Time adjustable .75 sec - 1.5 sec
"App!g!med: .B lbs/hr to 2 lbs/hr (40+ lbs/cubic ft density) on P100
"Agplqdllelg: .7 lbslhr to 1 .5 lbs/hr (40+ lbs/cubic ft iensity) cn P75
MEDIUM: 1.75 sec On Time is approximaiely 2.5 lbs/hr (P100); 1.7 lbslhr (P75)
+-
oN
1.75
--'l<--
sec i
oFF
2.25 sec
{-- oN --+i<- oFF
2.25 sec
1.75 sec |
i
oN
I
--'l<-I
oFf
*-- on ->i
!
I
I
HIGH: 2.5 sec On Time
<-
oN
is approximately 3.1 lbs/hr (P100); 2.3 ibs/'hr {P75)
=J.-orr-j: o;;
2.5 sec
MAXIMUM: continuous On Tirne
i
i
11194
3#l*l{iryg
America'sqettingtheGlei-
- approximately
5.5 !bs/hr (P100); 3.5 lbv'hr (P75)
1770LaurelStreet.P.O.Box179.Florence,OR92.{39.503i997-2666.FAX5A31997-8986
1,