Durabuilt Slab Dimensions (from A5 Assembly Guide)

Durabuilt Slab Dimensions (from A5 Assembly Guide)

Durabuilt Products
Flat, Gable and Skillion Roof Sheds
Rebated Slab Dimensions
Above Concrete slab for Durabuilt Sheds with rebated edges.
Permanent Anchoring on a Concrete Slab.
There are three methods of laying concrete slabs for
permanently fixing Durabuilt Sheds and Aviaries.
They are:
Method A. Sheds maybe anchored to the ground and a
concrete slab poured inside. Galvanised surfaces should
be protected from direct contact with wet concrete
(which has a corrosive action) by taping a strip of plastic
sheet up the wall for approximately 150-200mm and
laying it out from the wall for some distance.
Method B. Sheds may maybbe anchored to an existing
concrete slab using Durabuilt Concrete Fixing Set (anchor
brackets and bolts). Use the recommended number of
sets as per table. Each set contains eight (8) brackets and
bolts.
Method C. A concrete slab with a stepped, or rebated,
edge as shown above will prevent rainwater from running
under the wall of the shed. Refer to table over.
Concrete Fixing Set Anchoring Instructions.
Durabuilt Sheds and Aviaries are permanently fixed to a
concrete slab in just three simple steps.
Step 1. Using a 6.5mm diameter masonry drill, position
the bracket and drill a 50mm deep (approximately) hole
in the concrete
Step 2. Drive the masonry anchor through the bracket
into the anchor hole until the head is firmly seated against
the bracket. Be sure the anchor is driven to the required
embedment depth.
Step 3. Drill through bracket into wall of Shed with 6mm
steel drill and secure with nut, bolt and washer supplied.
Two people will be needed for this.
Durabuilt Products
Flat, Gable and Skillion Roof Sheds
Rebated Slab Dimensions
Size of Shed/Aviary
Side A
x
Side B
Number of Sets of 8 anchors
0.75 metres
1.50 metres
2.25 metres
3.00 metres
3.75 metres
4.50 metres
5.25 metres
6.00 metres
7.50 metres
x
x
x
x
x
x
x
x
x
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0.75 metres
0725 mm
1460 mm
2205 mm
2950 mm
3695 mm
4425 mm
5170 mm
5915 mm
7405 mm
x
x
x
x
x
x
x
x
x
0725 mm
0725 mm
0725 mm
0725 mm
0725 mm
0725 mm
0725 mm
0725 mm
0725 mm
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
Two anchor set (minimum)
Two anchor set (minimum)
Two anchor set (minimum)
Two anchor set (minimum)
1.50 metres
2.25 metres
3.00 metres
3.75 metres
4.50 metres
5.25 metres
6.00 metres
7.50 metres
x
x
x
x
x
x
x
x
1.50 metres
1.50 metres
1.50 metres
1.50 metres
1.50 metres
1.50 metres
1.50 metres
1.50 metres
1460 mm
2205 mm
2950 mm
3695 mm
4425 mm
5170 mm
5915 mm
7405 mm
x
x
x
x
x
x
x
x
1460 mm
1460 mm
1460 mm
1460 mm
1460 mm
1460 mm
1460 mm
1460 mm
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
1.50 metres
2.25 metres
3.00 metres
3.75 metres
x
x
x
x
1.90 metres
1.90 metres
1.90 metres
1.90 metres
1460 mm
2205 mm
2950 mm
3695 mm
x
x
x
x
1840 mm
1840 mm
1840 mm
1840 mm
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
2.25 metres
3.00 metres
3.75 metres
4.50 metres
5.25 metres
6.00 metres
7.50 metres
x
x
x
x
x
x
x
2.25 metres
2.25 metres
2.25 metres
2.25 metres
2.25 metres
2.25 metres
2.25 metres
2205 mm
2950 mm
3695 mm
4425 mm
5170 mm
5915 mm
7405 mm
x
x
x
x
x
x
x
2205 mm
2205 mm
2205 mm
2205 mm
2205 mm
2205 mm
2205 mm
One anchor set (minimum)
One anchor set (minimum)
One anchor set (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
3.00 metres
3.75 metres
4.50 metres
5.25 metres
6.00 metres
7.50 metres
x
x
x
x
x
x
3.00 metres
3.00 metres
3.00 metres
3.00 metres
3.00 metres
3.00 metres
2950 mm
3695 mm
4425 mm
5170 mm
5915 mm
7405 mm
x
x
x
x
x
x
2950 mm
2950 mm
2950 mm
2950 mm
2950 mm
2950 mm
One anchor set (minimum)
One anchor set (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
3.75 metres
4.50 metres
5.25 metres
6.00 metres
7.50 metres
x
x
x
x
x
3.75 metres
3.75 metres
3.75 metres
3.75 metres
3.75 metres
3695 mm
4425 mm
5170 mm
5915 mm
7405 mm
x
x
x
x
x
3695 mm
3695 mm
3695 mm
3695 mm
3695 mm
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)
Two anchor sets (minimum)