1 suelo radiante-refrescante.indd
Transcription
1 suelo radiante-refrescante.indd
GENERAL CATALOGUE 2012 UNDERFLOOR HEATING-COOLING SOLAR SYSTEMS HEATING and PLUMBING GENERAL CATALOGUE 2012 ORKLI, S. Coop. Ctra. Zaldibia, s/n / E - 20240 Ordizia (Gipuzkoa) Tel.: + 34 943 80 94 80 / Fax: + 34 943 80 52 41 E-mail: [email protected] www.orkli.com www.orkli.com index 01 Underfloor Heating / Cooling ......... 2 Underfloor heating systems ....................... 8 Heating system for commercial establishments ......................................... 16 Underfloor heating plates ........................ 18 Tube ....................................................... 23 Hydraulic units for underfloor heating systems ................ 24 Hydraulic units for underfloor heating/cooling systems .......................... 26 Underfloor heating/cooling distribution equipment ............................ 28 Modular manifolds .................................. 34 Distribution units for combined underfloor heating/cooling installations and radiators ....................... 38 Components............................................ 40 Components for control .......................... 42 Project..................................................... 46 General conditions to guarantee ............. 47 Coverage certificate................................. 48 02 Manifolds and distribution equipment . 52 * Underfloor heating/cooling distribution equipment ............................ 54 Modular manifolds ................................... 60 Modular manifolds with brass male quick couplers ................................. 66 Distribution units for combined underfloor heating/cooling installations and radiators ........................ 68 Radiators distribution equipment ............. 70 Domestic water distribution equipment ... 76 Components for distribution equipment ............................................... 77 Coupling to pipe accessories ................... 86 Note: Any non included reference in the catalogue, request delivery delay 03 Solar heating systems........................... 90 AVIS TECHNIQUE CSTB 001/004834 001/004835 Solar system with integrated OKSOL-150 tank ..................................... 92 Drain-Unit; hydraulic unit with drain-back system ................................... 94 Drain-Unit; dual hydraulic unit with drain back system ........................... 98 Hydraulic units for major installations ................................ 100 Solar hydraulic units high efficiency ....................................... 102 Hydraulic pumping units with integrated control .................................. 104 Hydraulic pumping units without regulation .............................................. 106 Indirect heat exchange solar kit ................................................ 108 Solar dhw kit ......................................... 110 Zone valves ........................................... 112 Safety valves.......................................... 113 Flowmeters............................................ 113 Safety groups......................................... 113 Compensation valves ............................ 113 Drain valves/air separators .................... 114 Mixing valves ........................................ 114 Adjustment for solar heating installations 114 Solar expansion vessels .......................... 114 Accessories for expansion vessels .......... 115 04 Valves and fittings for radiators ... 116 Home refurbishment plan: valves with thermostatic heads .............. Thermostatic head valves ...................... Thermostatic valves: bitube, monotube, conecta system...................................... Thermostatic unit .................................. Special valves for bathrooms: Deluxe series ......................................... Manual valves: bitube, monotube ......... Lockshields ............................................ Purging devices ..................................... Hydraulic modules for radiators with integrated taps ...................................... Accessories ........................................... 118 124 125 133 134 139 142 145 146 147 05 Zone valves ................................. 158 Non detachable zone valves ................. 160 Detachable zone valves ........................ 162 06 Valves and safety groups ............ 168 Safety valves.......................................... Safety groups ....................................... Safety group kit ..................................... Blister packs safety groups .................... Safety units supplied on “trays .............. Compensation valves ............................ Accessories ........................................... 170 171 174 175 176 176 177 07 Climate control............................ 178 Thermostats and chronothermostats ...... Thermostat and chronothermostats by radio frecuency ..................................... External climate control ......................... Thermocyclic control ............................ Climate control accessories ................... 180 180 181 182 183 08 Security products ........................ 184 09 Thermocouples ........................... 187 10 Spare parts ................................. 189 General purchasing conditions ...... 193 Guarantee ....................................... 196 Commercial network ....................... 194 Underfloor 01 Heating/Cooling 01 energy efficiency Underfloor Heating / Cooling Underfloor heating systems Heating system for commercial establishments Underfloor heating plates Tube Hydraulic units for underfloor heating systems Hydraulic units for underfloor heating/cooling systems Underfloor heating/cooling distribution equipment Modular manifolds Distribution units for combined underfloor heating/cooling installations and radiators Components Components for control Project General conditions to guarantee Coverage cer tificate UNDERFLOOR HEATING/COOLING you can’t see it... Underfloor 01 Heating/Cooling energy efficiency All-round Solution The best all-round Underfloor Heating and Cooling system to adapt to your needs. It's all advantages The All-round Underfloor Heating and Cooling system has clear advantages: • Ideal temperature distribution. • Uniform temperature. • Energy savings: at least 15%. • Attractive appearance. • Healthy: natural humidity, no dust. • Clean. • Compatible with any energy type. Ideal for renewable energies. ...but you can feel it Major installations Greenhouses • Flower greenhouse in the Pagoeta Natural Park (Guipuzcoa) • Experimental tomato greenhouse, Guipuzcoa Regional Government Supermarkets • Eroski Supermarket in Santurce (Vizcaya) Homes for the Elderly • Residence In San Salvador de Oña (Burgos) • Clergymen's residence in Beloso (Pamplona) • Calzada de Guernica Home (Vizcaya) • Arangoitia Home (Beasain) • COCOPE Foundation Elderly People’s Home in Peñafiel (Valladolid) • Guadalajara Home • Day Centre in La Coruña • Villanubla Elderly People’s Home (Valladolid) • Elderly people's home in Montauban (France) Schools and sports centres • School in Las Matas (Madrid) • Kindergarten in Zarautz (Gipuzkoa) • State School in Santibañez (Caceres) • School, sports and cultural centre in Caudete (Albacete) • San Agustín de Guadalix School (Madrid) • School in Colmenar Viejo (Madrid) • Anoeta Ikastola School (Guipuzcoa) • Gym at the Urdaneta de Ordizia School (Guipuzcoa) • “Children’s House” in Alovera (Guadalajara) • Music school and archaeological interpretation centre in Salvatierra (Álava) • Altea Sports Centre (Alicante) • Athletics ground in Burgos • Physiotherapy centre in Bergara (Guipuzcoa) • School in Ejea de los Caballeros (Zaragoza) • Nursery schools in Beasain, Lazkao and Ormaiztegi (Guipuzcoa); La Cistérniga (Valladolid); San Antolín in Palencia; Ibeas de Juarros (Burgos); Salburua (Vitoria); Carcasonne (France), Montauban (Francia) • School in Tolosa (Guipuzcoa) • Bressol Schools (Barcelona) • María Soriano Special Education Centre in Madrid • Reform of Castilla León Agricultural Technology Institute Tel.: +34 943 80 51 80 Fax: +34 943 80 52 41 Residential blocks • 64 homes in Medina del Campo (Valladolid) • 46 homes for the San Cristóbal Cooperative - phase XXVIII (Valladolid) • 26 homes at Calle Licenciado Poza nº 32, Bilbao (Vizcaya) • 45 sheltered flats in Lutxana (Vizcaya) • 168 homes in Sabadell (Barcelona) • 50 homes in Sant Cugat del Vallès (Barcelona) • Students’ residence in Mieres (Asturias) • 36 single-family homes in Cigales (Valladolid) Hotels • Hotel in Vitoria • Guesthouse in Ampurias Industrial buildings, shops and warehouses • Riventi Factory building (Burgos) • High-efficiency industrial building in Meco (Madrid) • Warehouse in Gregori (Lleida) • Berogas plumbing shop in Tolosa (Guipuzcoa) • Elosegi sanitary product display shop in Beasain (Guipuzcoa) • Furniture display shop on the La Paz Industrial Estate in Teruel • Renteria Municipal Market (Guipuzcoa) • Tile-making establishment in Zaldibia (Guipuzcoa) • Industrial building in Alcasa (Valladolid) Sundry • Fire station in Madrid • Cardedeu Library (Barcelona) • Valladolid National Police Station • Valladolid Military Hospital • Cultural Centre in Alcobendas (Madrid) • Integrated Emergency Centre in Alcorcón (Madrid) • Castilla y León Agricultural Technical Institute on the Zamadueñas estate (Valladolid) • Atapuerca Visitor Reception Centre in Ibeas de Juarros (Burgos) • Health Centre in Aguilar de Campoo (Palencia) • Caprotti Palace (Ávila) • Teruel Agricultural Study and Development Centre • Teruel Airport • San Telmo Museum (San Sebastian) • Beasain Town Hall • Chemist's shop in Bilbao • Igartza Palace (Beasain) • ERM military base (Muret – Toulouse) • Cazadores Alpinos Chasseur Alpin de Varce military base (Var) www.orkli.com oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING SYSTEMS Underfloor Heating Certification For an underfloor heating/cooling system to be considered a quality system it must be certified by an external company. In Spain, AENOR certifies that this body has ensured that the complete ORKLI system (the design of the projects and all the materials used in them) complies with the UNEEN 1264 standard for underfloor heating/cooling. Before issuing its certificate, AENOR performs testing at the CEIS laboratories in Madrid with a real underfloor heating system calculated by ORKLI, comparing the values obtained with those calculated in the design created at ORKLI’s offices. It then compares this value with those required in the UNE-EN 1264 standard. If all the parameters are correct, it issues the certificate. 001/004834 001/004835 SRPT-16 SRPT-20 In France, the CSTB is the body certifying that the ORKLI underfloor heating/cooling system complies with the French standards. AVIS TECHNIQUE CSTB 20/10-205 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 7 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING SYSTEMS SRPT-16 001/004834 SRPT-16 Mortar 2 Floor slab manifolds control + Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 3 16 mm 45 mm 86 mm 1 25 mm + 8 1 components SRPT-16 project installer assistance service + www.orkli.com 2 + 3 coverage certificate + oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING SYSTEMS SRPT-16 Cross-linked polyethylene tube using the peroxide method (PEX-A) with EVOH antidiffusion barrier Studded multidirectional insulating plate • Material: EPS. • Pipe: 16 – 20 mm. • Pipe configuration: the pipe may be installed in several directions. • Pitch: 75 mm. AVIS TECHNIQUE CSTB 14/07-1149 • Stud shape: undercut. • Density: 30 kg/m3. • Acoustic insulation: ALw= 16 db. • Note: consult price and availability for other thicknesses and densities. DESCRIPTION Ø16x1,8 Ø16x1,8 Ø16x1,8 Ø16x1,8 DESCRIPTION m2K/W R=0,75 R=1,25 m2K/W R=1,7 m2K/W R=2,1 m2K/W DIMENSION (mm) ARTICLE ARTICLE M./COIL SRTBA16-100 SRTBA16-120 SRTBA16-200 SRTBA16-500 €/M 100 120 200 500 PIECES/BOX €/PANEL 1075x750x25 1075x750x43 1075x750x58 SRPAN25-P SRPAN43-P SRPAN58-P 11 8 7 1075x750x72 SRPAN72-P 5 Polyethylene foam flanking strip • Thickness: 7mm. • Density: 33 kg/m3. DESCRIPTION With self-adhesive backing ARTICLE M./COIL SRBAN-2 50 €/M Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 9 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING SYSTEMS SRPT-20 001/004835 SRPT-20 Mortar 2 Floor slab manifolds control + Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 3 20 mm 45 mm 90 mm 1 2 25 mm + 10 1 components SRPT-20 project installer assistance service + www.orkli.com + 3 coverage certificate + oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING SYSTEMS SRPT-20 Cross-linked polyethylene tube using the peroxide method (PEX-A) with EVOH antidiffusion barrier Studded multidirectional insulating plate • Material: EPS. • Pipe: 16 – 20 mm. • Pipe configuration: the pipe may be installed in several directions. • Pitch: 75 mm. • Stud shape: undercut. • Density: 30 kg/m3. • Acoustic insulation: ALw= 16 db. • Note: consult for price and availability for other thicknesses and densities. DESCRIPTION Ø20x1,9 Ø20x1,9 Ø20x1,9 Ø20x1,9 DESCRIPTION m2K/W R=0,75 R=1,25 m2K/W R=1,7 m2K/W R=2,1 m2K/W DIMENSION (mm) ARTICLE ARTICLE M./COIL SRTBA20-100 SRTBA20-120 SRTBA20-200 SRTBA20-500 €/M 100 120 200 500 PIECES/BOX €/PANEL 1075x750x25 1075x750x43 1075x750x58 SRPAN25-P SRPAN43-P SRPAN58-P 11 8 7 1075x750x72 SRPAN72-P 5 Polyethylene foam flanking strip • Thickness: 7mm. • Density: 33 kg/m3. DESCRIPTION With self-adhesive backing ARTICLE M./COIL SRBAN-2 50 €/M Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 11 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING SYSTEMS SRPL-16 Ideal for refurbishments. SRPL-16 1 3 Floor slab manifolds control + Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 installer assistance service + www.orkli.com + 3 5 mm Mortar 2 16 mm 30 mm 56 mm 2 + 12 1 components SRPL-16 project coverage certificate + oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING SYSTEMS SRPL-16 Multilayer pipe Multi-layer heat reflective insulation • Note: for other diameters and lengths of the coil, • Material: multilayer. consult for price and availability. • Pitch: 50 mm. • Acoustic insulation: ALw= 22 db. DESCRIPTION Ø16x2 DESCRIPTION R=0,75 m2K/W DIMENSION (mm) ARTICLE M/ROLL 12,66x1,58x0,005 SRTR5 20 ARTICLE SRTM16-200 M./COIL €/M 200 €/M Fixing rail for multilayer panel DESCRIPTION Rail for Ø 16 tube ARTICLE M/RAIL SRCAR16-L 2 €/M. Heat reflector plate installation diagram 1. Place the fixing rail. 2. Place the pipe in the fixing rail. Tel.: +34 943 80 94 80 3. Final installation diagram. Fax: +34 943 80 52 41 www.orkli.com 13 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING SYSTEMS SRPL-20 Ideal for refurbishments. SRPL-20 1 3 Floor slab manifolds control + Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 installer assistance service + www.orkli.com + 3 5 mm Mortar 2 20 mm 30 mm 55 mm 2 + 14 1 components SRPL-20 project coverage certificate + oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING SYSTEMS SRPL-20 Multilayer pipe Multi-layer heat reflective insulation • Note: for other diameters and lengths of the coil, • Material: multilayer. consult for price and availability. • Pitch: 50 mm. • Acoustic insulation: ALw= 22 db. DESCRIPTION DESCRIPTION R=0,75 m2K/W DIMENSION (mm) ARTICLE M/ROLL 12,66x1,58x0,005 SRTR5 20 €/M Ø20x2 ARTICLE SRTM20-200 M./COIL €/M 200 Fixing rail for multilayer panel DESCRIPTION Rail for Ø 20 tube ARTICLE M/RAIL SRCAR20-L 2 €/M. Heat reflector plate installation diagram 1. Place the fixing rail. 2. Place the pipe in the fixing rail. Tel.: +34 943 80 94 80 3. Final installation diagram. Fax: +34 943 80 52 41 www.orkli.com 15 UNDERFLOOR HEATING/COOLING HEATING SYSTEM FOR COMMERCIAL ESTABLISHMENTS This installation system uses the heat emitted by cold chambers for ambient heating in commercial establishments, meaning no power source is required for heating. The underfloor heating system installed beside the cold chamber emits heat in both winter and summer and the area is therefore not an excessively cold zone in summer, creating comfort for people transiting through these areas (it is a proven fact that purchasing customers spend a much longer time in these cooled areas). An added advantage is the fact that when an underfloor heating installation is used to dissipate the heat emitted by the cooling circuit, no condenser needs to be fitted and therefore no evacuation chimney needs to be installed. Consequently, as no condenser needs to be fitted, the installation makes much less noise. 16 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com d patente oor 01 Underfl Heating/Cooling HEATING SYSTEM FOR COMMERCIAL ESTABLISHMENTS COOLING SYSTEM FOR COMMERCIAL ESTABLISHMENTS + manifolds + control + installer assistance service + Tel.: +34 943 80 94 80 coverage certificate + Fax: +34 943 80 52 41 www.orkli.com 17 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING PLATES The EN 1264 European underfloor heating standard states that the insulating plate is to have a different thermal resistance depending on where the underfloor heating is to be installed. The thermal resistance values set by the standard are as follows: MINIMUM THERMAL RESISTANCE ACCORDING TO INSTALLATION PREMISES AND IN COMPLIANCE WITH THE UNE EN 1264 STANDARD Plate between heated rooms R= 0,75 m2K/W Plate on non-heated ground or space R = 1,25 m2K/W External temperatures Plate on overhang Up to 0ºC, R = 1,25 m2K/W Between 0 et -5ºC, R = 1,5 m2K/W Between -5 et -15ºC, R = 2 m2K/W 20ºC The applicable building regulations in different countries also stress the importance of thermal insulation of buildings to reduce CO2 emissions into the atmosphere. Using suitable underfloor heating insulation for each case, the underfloor heating standard and the building regulations can therefore both be complied with using one single element. 18 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING PLATES BUILDING REGULATIONS IN SPAIN In Spain, the Technical Building Code which took effect in 2006 and is mandatory, states the requirements to be fulfilled by buildings with regard to basic safety, habitability and environmental protection requirements. The Technical Building Code establishes thermal values for the building’s cladding: For floor insulation, the Technical Building Code states that the thermal resistance must be as follows: cladding R = 1,45 m2K/W (Climate zone A) VIZCAYA ASTURIAS LA CORUÑA GUIPÚZCOA CANTABRIA LUGO ÁLAVA PALENCIA LEÓN PONTEVEDRA BURGOS OURENSE NAVARRA LÉRIDA ZAMORA SORIA VALLADOLID R = 1,47 m2K/W (Climate zone B) GIRONA HUESCA LA RIOJA BARCELONA ZARAGOZA TARRAGONA SALAMANCA GUADALAJARA R = 1,54 m2K/W (Climate zone C) TERUEL ÁVILA MADRID CASTELLÓN CUENCA TOLEDO CÁCERES VALENCIA CIUDAD REAL BADAJOZ BALEARES R = 1,56 m2K/W (Climate zone D) ALBACETE ALICANTE CÓRDOBA HUELVA JAÉN MURCIA SEVILLA GRANADA R = 1,61 m2K/W (Climate zone E) ALMERIA MALAGA CÁDIZ SANTA CRUZ LAS PALMAS Note: The climate zones are as per the capitals. The climate zone may be affected by the altitude of the works in question. Taking into account both these values and the resistance established by the underfloor heating standard UNE-EN 1264, the least favourable value would need to be calculated for each case. This would be the resistance value all underfloor heating plates must have in order to comply with all of the requirements. SOUND INSULATION. Basic noise protection requirements (HR) The aim of the basic “Noise protection” requirement included in the Technical Building Code is to limit, inside buildings and under normal conditions of use, the risk of nuisance or illnesses that noise may cause to users as a result of the characteristics of their project, construction, use and maintenance. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 19 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING PLATES The values of noise that the building has to meet, are the following: FLOOR TYPE Brick partitioning or heavy pre-fabricated panels with elastic bands or resting on the floating floor Self-supporting panel partition Floor mass (kg/m2) ΔLW (dB) ΔLW (dB) 175 200 225 250 300 350 400 450 26 25 24 22 16 15 12 10 26 24 23 21 16 14 11 10 The plate used for underfloor heating means a thermal insulation value is already obtained. BUILDING REGULATIONS IN FRANCE In France, the heat insulation regulation RT2005, which took effect in 2006 and is mandatory, places a maximum limit on the energy consumption of new buildings for heating, ventilation, air conditioning, domestic hot water production and lighting. Between an overhang (balcony, etc.) and a floor. Plate on non-heated ground R= 1,7 m2K/W Plate on non-heated space R = 2,5 m2K/W Plate on overhang R = 2,78 m2K/W To choose properly the insulating panel, it is necessary to compare the values of thermal resistance according to EN 1264 and the thermal resistance of RT2005. The worst value is the one to choose. 20 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING PLATES did you know...? that all the components for underfloor heating-cooling for major installations have special prices? Consult. did you know...? that the studded multidirectional insulating plate has numerous advantages? • Undercut studs. • 15% more heat flow. • Pipe installed in several directions. • They are valid for 16 mm – 20 mm pipes. • They are multidirectional: the pipe is secured horizontally, vertically and diagonally. • The studs are undercut to firmly secure the pipe. • They have a tongue and groove system joining one plate to another, preventing thermal bridges from being created when the mortar is poured in. • They are plasticised to prevent damage to the EPS. • They combine the advantages of both smooth and studded plates, as they have smooth and studded parts. • The smooth parts allow the plate to be stepped on during installation work without causing damage to the studs. • They comply with the UNE EN 1264 Standard (we offer different plate thicknesses, obtaining different thermal resistances). • Sound impact insulation: 16 dB. • They are the same size as a European pallet, preventing damage on transport, and they are packed in cardboard boxes to prevent damage on both transport and installation. • They are made of fireproof material. Studded multidirectional insulating plate • Material: EPS. • Pipe: 16 – 20 mm. • Pipe configuration: the pipe may be installed in several directions. • Pitch: 75 mm. • Stud shape: undercut. • Density: 30 kg/m3. • Acoustic insulation: ALw= 16 db. • Note: consult for price and availability for other thicknesses and densities. DESCRIPTION DIMENSION (mm) R=0,75 m2K/W R=1,25 m2K/W R=1,7 m2K/W R=2,1 m2K/W 1075x750x25 1075x750x43 1075x750x58 1075x750x72 Tel.: +34 943 80 94 80 ARTICLE SRPAN25-P SRPAN43-P SRPAN58-P SRPAN72-P Fax: +34 943 80 52 41 PIECES/BOX €/PANEL 11 8 7 5 www.orkli.com 21 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING PLATES Smooth insulating plate Smooth plasticised insulation panel • Material: EPS. • Material: EPS. • Pitch: grids of 50 mm. • Pitch: grids of 50 mm. • Density: 30 kg/m3. • Density: 30 kg/m3. • Acoustic insulation: ALw= 16 db. • Acoustic insulation: ALw= 16 db. • Note: consult for price and availability for other thicknesses and • Note: consult for price and availability for other thicknesses and densities. densities. ARTICLE PIECES/BOX €/PANEL DESCRIPTION DIMENSION (mm) R=0,75 m2K/W R=1,25 m2K/W R=1,7 m2K/W R=2,1 m2K/W 1075x750x25 1075x750x43 1075x750x58 SRPAN25-L SRPAN43-L SRPAN58-L 19 12 9 1075x750x72 SRPAN72-L 6 DESCRIPTION DIMENSION (mm) R=0,75 m2K/W R=1,25 m2K/W R=1,7 m2K/W R=2,1 m2K/W 1075x750x25 1075x750x43 1075x750x58 1075x750x72 DESCRIPTION DIMENSION (mm) ARTICLE SRPAN25-LP SRPAN43-LP SRPAN58-LP SRPAN72-LP PIECES/BOX €/PANEL 19 12 9 7 Studded insulating plate • Material: EPS. • Pitch: 50 mm. • Pipe: 14 – 16 mm. • Stud shape: undercut. • Density: 30 kg/m3. • Acoustic insulation: ALw= 26 db. (article SRPAN25-PA). • Note: consult for price and availability for other thicknesses and R=0,38 m2K/W R=0,75m2K/W densities. 1400x800x11 1400x800x25 ARTICLE SRPAN11-P SRPAN25-PA PIECES/BOX €/PANEL 12 8 Multi-layer heat reflective insulation • Material: multilayer. did you know...? • Pitch: 50 mm. • Acoustic insulation: ALw= 22 db. that the multi-layer heat reflective insulation panel is ideal for refurbishments? As it is a flat panel (low thickness), height is not required for the installation. DESCRIPTION R=0,75 m2K/W 22 DIMENSION (mm) ARTICLE M/ROLL 12,66x1,58x0,005 SRTR5 20 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 €/M that a thickness of just 5 cm complies with the minimum thermal resistance requirements of 0.75 m2K/W?. www.orkli.com oor 01 Underfl Heating/Cooling TUBE Cross-linked polyethylene tube using the peroxide method (PEX-A) with EVOH antidiffusion barrier Ø 16 Multilayer pipe AVIS TECHNIQUE CSTB 14/07-1149 • Note: for other diameters and lengths of the coil, consult for price and availability. • Note: for other diameters and lengths of the coil, consult for price and availability. DESCRIPTION Ø16x1,5 Ø16x1,8 Ø16x1,8 Ø16x1,8 Ø16x1,8 Ø20x1,9 Ø20x1,9 Ø20x1,9 Ø20x1,9 ARTICLE SRTBA16F-200 SRTBA16-100 SRTBA16-120 SRTBA16-200 SRTBA16-500 SRTBA20-100 SRTBA20-120 SRTBA20-200 SRTBA20-500 M./COIL 200 100 120 200 500 100 120 200 500 €/M DESCRIPTION Ø16x2 Ø20x2 Tel.: +34 943 80 94 80 ARTICLE SRTM16-200 SRTM20-200 Fax: +34 943 80 52 41 M./COIL €/M 200 200 www.orkli.com 23 UNDERFLOOR HEATING/COOLING HYDRAULIC UNITS FOR UNDERFLOOR HEATING SYSTEMS SINGLE POINT HYDRAULIC UNITS Single point hydraulic units consist of 2 shut-off valves, 2 thermometers, a single point mixing valve and a pump (180 mm). Including all these components in a single unit provides major advantages such as easy installation, savings on both materials and labour costs and the guarantee offered by a unit with all its components mounted. 24 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling HYDRAULIC UNITS FOR UNDERFLOOR HEATING SYSTEMS • • • • • • • Maximum operating temperature: 110ºC. Maximum operating pressure: 6 bar. Connections: 1” female. Centre distance: 125 mm. Differential pressure valve scale: 0.2 - 0.6 bar. Mixing valve temperature range: 20ºC-50ºC. Hydraulic characteristics (page 49). • Materials: - Insulation: EPP. - Copper pipes. - Brass bodies. - Seals: EPDM. • Pump characteristics: - Centre distance: 180 mm. - Connections: 1 ½”. DESCRIPTION PUMP 1" unit with shut-off valve, single point mixing valve and thermometers 1" unit with shut-off valve, single point mixing valve, thermometers and differential pressure valve RS 25/6-3 1" unit with shut-off valve, single point mixing valve and thermometers YONOS Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX SR1100 1 SR1110 1 SR1200 1 Fax: +34 943 80 52 41 € www.orkli.com 25 UNDERFLOOR HEATING/COOLING HYDRAULIC UNITS FOR UNDERFLOOR HEATING/COOLING SYSTEMS VARIABLE POINT HYDRAULIC UNITS Variable point hydraulic units consist of 2 shut-off valves, 2 thermometers, a motorised mixing valve and a pump (180 mm). Including all these components in a single unit provides major advantages such as easy installation, savings on both materials and labour costs and the guarantee offered by a unit with all its components mounted. 26 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling HYDRAULIC UNITS FOR UNDERFLOOR HEATING/COOLING SYSTEMS • • • • • • • Maximum operating temperature: 110ºC. Maximum operating pressure: 6 bar. Connections: 1” female. Centre distance: 125 mm. Differential pressure valve scale: 0.2 - 0.6 bar. Mixing valve temperature range: 20ºC-50ºC. Motor: - 3-point actuator. - 230 V. - Connection cable: 1.5 m. - 90º rotation time: 60 s. - Torque: 6 Nm. • Hydraulic characteristics (page 49). • Materials: - Insulation: EPP. - Copper pipes. - Brass bodies. - Seals: EPDM. • Pump characteristics: - Centre distance: 180 mm. - Connections: 1 ½”. DESCRIPTION PUMP 1" unit with shut-off valve, motorised mixing valve and thermometers 1" unit with shut-off valve, motorised mixing valve, thermometers and differential pressure valvel RS 25/6-3 1" unit with shut-off valve, motorised mixing valve and thermometers YONOS Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX SR2100 1 SR2130 1 SR2200 1 Fax: +34 943 80 52 41 € www.orkli.com 27 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT SINGLE POINT AND VARIABLE POINT DISTRIBUTION UNITS The single point and variable point distribution units are designed to provide professionals with products that will help them carry out their projects, notably improving the quality of the final installation. We have carefully designed this product down to the last detail to make it a competitive solution and so that it really is “all advantages”: safety and reliability, savings on materials and labour costs and quick and easy installation, resulting in a fullyguaranteed product. in June le b a il a v A 28 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT SINGLE POINT DISTRIBUTION UNIT WITH LOCKSHIELDS SINGLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS • Components include: manifold with thermostatic valves, manifold • Components include: manifold with thermostatic valves, manifold with lockshields, 2 drain valves, 2 supports, 2 drain valves with with flow regulators, 2 drain valves, 2 supports, 2 drain valves with filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure valve, 2 shut-off valves and a metal cabinet. valve, 2 shut-off valves and a metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency • Note: High-efficiency pumps with a variable flow. ARTICLE PIECES/BOX 42AC1AAAB000 42BC1AAAB000 42CC1AAAB000 42DC1AAAC000 42EC1AAAC000 42FC1AAAC000 42GC1AAAD000 42HC1AAAD000 42IC1AAAD000 42JC1AAAL000 42KC1AAAL000 42AC1ABAB000 42BC1ABAB000 42CC1ABAB000 42DC1ABAC000 42EC1ABAC000 42FC1ABAC000 42GC1ABAD000 42HC1ABAD000 42IC1ABAD000 42JC1ABAL000 42KC1ABAL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE PIECES/BOX 42AD1AAAB000 42BD1AAAB000 42CD1AAAB000 42DD1AAAC000 42ED1AAAC000 42FD1AAAC000 42GD1AAAD000 42HD1AAAD000 42ID1AAAD000 42JD1AAAL000 42KD1AAAL000 42AD1ABAB000 42BD1ABAB000 42CD1ABAB000 42DD1ABAC000 42ED1ABAC000 42FD1ABAC000 42GD1ABAD000 42HD1ABAD000 42ID1ABAD000 42JD1ABAL000 42KD1ABAL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 29 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT VARIABLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS FOR HEATING VARIABLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS FOR HEATING AND COOLING • Components include: manifold with thermostatic valves, manifold • Components include: manifold with thermostatic valves, manifold with flow regulators, 2 drain valves, 2 supports, 2 drain valves with with flow regulators, 2 drain valves, 2 supports, 2 drain valves with filters, 1 motorised mixing valve, 1 pump, 1 differential pressure filters, 1 motorised mixing valve, 1 pump, 1 differential pressure valve, 1 flow sensor, 1 central regulating unit for heating, 1 external valve, 1 flow sensor, 1 central regulation unit for heating and cooling, sensor, 1 ambient temperature sensor, 2 shut-off valves and a metal 1 external sensor, 1 condensation sensor, 2 shut-off valves and a cabinet. metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE • Note: High-efficiency pumps with a variable flow. PIECES/BOX 42AD1AABB000 42BD1AABB000 42CD1AABB000 42DD1AABC000 42ED1AABC000 42FD1AABC000 42GD1AABD000 42HD1AABD000 42ID1AABD000 42JD1AABL000 42KD1AABL000 42AD1ABBB000 42BD1ABBB000 42CD1ABBB000 42DD1ABBC000 42ED1ABBC000 42FD1ABBC000 42GD1ABBD000 42HD1ABBD000 42ID1ABBD000 42JD1ABBL000 42KD1ABBL000 € 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency Note: Any non included reference in the catalogue, request delivery delay. 30 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 DESCRIPTION www.orkli.com ARTICLE PIECES/BOX 42AD1AACB000 42BD1AACB000 42CD1AACB000 42DD1AACC000 42ED1AACC000 42FD1AACC000 42GD1AACD000 42HD1AACD000 42ID1AACD000 42JD1AACL000 42KD1AACL000 42AD1ABCB000 42BD1ABCB000 42CD1ABCB000 42DD1ABCC000 42ED1ABCC000 42FD1ABCC000 42GD1ABCD000 42HD1ABCD000 42ID1ABCD000 42JD1ABCL000 42KD1ABCL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT DISTRIBUTION EQUIPMENT WITH LOCKSHIELDS • The components are easily removable for repair. • The components are easily removable for repair. • Standpipe entry can easily be changed from left to right or vice versa. • Standpipe entry can easily be changed from left to right or vice versa. • Drain valve replaceable with no need to drain installation. • Drain valve replaceable with no need to drain installation. • A manometer may be fitted. • A manometer may be fitted. • Filters to prevent dirt from entering the • Filters to prevent dirt from entering the installation. installation. • The drain valve may be fitted in various positions, so that the manifold • The drain valve may be fitted in various positions, so that the manifold can be fitted as required. can be fitted as required. • Add 2,5 € to install the manifold in the box. (See page 85). • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Other combinations, upon request. reference). • Other combinations, upon request. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3280442 3380442 3480442 3580442 3680442 3780442 3880442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5280552 5380552 5480552 5580552 5680552 5780552 5880552 5980552 6080552 6180552 6280552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8280662 8380662 8480662 8580662 8680662 8780662 8880662 8980662 9080662 9180662 9280662 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3285442 3385442 3486442 3586442 3686442 3787442 3887442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5285552 5385552 5486552 5586552 5686552 5787552 5887552 5987552 6088552 6188552 6288552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8285662 8385662 8486662 8586662 8686662 8787662 8887662 8987662 9088662 9188662 9288662 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 31 UNDERFLOOR HEATING/COOLING UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT DISTRIBUTION UNITS WITH FLOW REGULATORS • The components are easily removable for repair. • The components are easily removable for repair. • Standpipe entry can easily be changed from left to right or vice versa. • Standpipe entry can easily be changed from left to right or vice versa. • Drain valve replaceable with no need to drain installation. • Drain valve replaceable with no need to drain installation. • A manometer may be fitted. • A manometer may be fitted. • Filters to prevent dirt from entering the • Filters to prevent dirt from entering the installation. installation. • The drain valve may be fitted in various positions, so that the manifold • The drain valve may be fitted in various positions, so that the manifold can be fitted as required. can be fitted as required. • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). reference). • Other combinations, upon request. DESCRIPTION 3/4" 1" 1 1/4" • Other combinations, upon request. ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3290442 3390442 3490442 3590442 3690442 3790442 3890442 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 5290552 5390552 5490552 5590552 5690552 1 1 1 1 1 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5790552 5890552 5990552 6090552 6190552 6290552 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8290662 8390662 8490662 8590662 8690662 8790662 8890662 8990662 9090662 9190662 9290662 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION 3/4" 1" 1 1/4" ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3295442 3395442 3496442 3596442 3696442 3797442 3897442 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 5295552 5395552 5496552 5596552 5696552 1 1 1 1 1 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5797552 5897552 5997552 6098552 6198552 6298552 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8295662 8395662 8496662 8596662 8696662 8797662 8897662 8997662 9098662 9198662 9298662 1 1 1 1 1 1 1 1 1 1 1 Note: In modular manifolds and distribution equipment with lockshields, same discount as manifolds and distribution equipment section. Note: Any non included reference in the catalogue, request delivery delay. 32 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € oor 01 Underfl Heating/Cooling UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT DISTRIBUTION UNITS WITH PRE-MOUNTED MODULAR MANIFOLDS did you know...? that they prevent condensation in underfloor cooling systems? • The components are easily removable for repair. • Outlet thread: M24x1,5. • Other combinations, upon request. • 3/4" Euroconus, upon request. DESCRIPTION 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways ARTICLE PIECES/BOX 5290552M 5390552M 5490552M 5590552M 5690552M 5790552M 5890552M 5990552M 6090552M 6190552M 6290552M 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 33 UNDERFLOOR HEATING/COOLING MODULAR MANIFOLDS did you know...? that a fixing support must be included for every 4 modules? START MODULE Start module Shut-off valve DESCRIPTION ARTICLE PIECES/BOX Start module E-26795 1 € DESCRIPTION ARTICLE PIECES/BOX 1" Shut-off valve for impulse without thermometer 1" Shut-off valve for impulse with thermometer 1" Shut-off valve for return without thermometer 1" Shut-off valve for return with thermometer E-23147 E-23148 E-25232 E-25233 24 24 24 24 ARTICLE PIECES/BOX € INTERMEDIATE MODULES Module with M28x1,5 thermostatic valve DESCRIPTION Module with flow regulator ARTICLE 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus PIECES/BOX 5140000 5140000J 5140000H € 1 1 1 DESCRIPTION 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus 5130000 5130000J 5130000H € 1 1 1 Module with lockshield DESCRIPTION 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus 34 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com ARTICLE 5120000 5120000J 5120000H PIECES/BOX 1 1 1 € oor 01 Underfl Heating/Cooling MODULAR MANIFOLDS END MODULE End module End module with thermostatic valve DESCRIPTION ARTICLE PIECES/BOX With drain valve and drain tap E-26796 1 € Outlet thread M24x1,5 ARTICLE Outlet thread M24x1,5 End module with flow regulator DESCRIPTION DESCRIPTION 5140000MF PIECES/BOX € 1 End module with lockshield ARTICLE 5130000MF PIECES/BOX € 1 DESCRIPTION ARTICLE Outlet thread M24x1,5 5120000MF PIECES/BOX € 1 START/END MODULE Start/end module with drain valve and drain tap Module with M28x1,5 thermostatic valve DESCRIPTION ARTICLE PIECES/BOX Start/end module with drain valve and drain tap E-23146 1 € Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus Module with flow regulator DESCRIPTION DESCRIPTION 5140000B 5140000JB 5140000HB PIECES/BOX € 1 1 1 Module with lockshield ARTICLE 5130000B 5130000JB 5130000HB PIECES/BOX 1 1 1 € DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus Tel.: +34 943 80 94 80 5120000B 5120000JB 5120000HB Fax: +34 943 80 52 41 PIECES/BOX € 1 1 1 www.orkli.com 35 UNDERFLOOR HEATING/COOLING MODULAR MANIFOLDS START/END MODULES + SHUT-OFF VALVE UNIT Start/end module with drain valve and drain tap DESCRIPTION ARTICLE PIECES/BOX Start/end modules + shut-off valve unit E-23145 1 € Module with M28x1,5 thermostatic valve DESCRIPTION Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus DESCRIPTION Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 36 Tel.: +34 943 80 94 80 5140000BC 5140000JBC 5140000HBC PIECES/BOX € 1 1 1 Module with lockshield Module with flow regulator DESCRIPTION ARTICLE ARTICLE PIECES/BOX 5130000BC 5130000JBC 5130000HBC Fax: +34 943 80 52 41 € 1 1 1 www.orkli.com Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus ARTICLE 5120000BC 5120000JBC 5120000HBC PIECES/BOX 1 1 1 € oor 01 Underfl Heating/Cooling MODULAR MANIFOLDS M30 X 1,5 MODULES Module with M30x1,5 thermostatic valve Module with M30x1,5 thermostatic valve DESCRIPTION 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus ARTICLE 5140000A 5140000JA 5140000HA PIECES/BOX 1 1 1 € DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 5140000AB 5140000JAB 5140000HAB € PIECES/BOX 1 1 1 Module with M30x1,5 thermostatic valve DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 5140000ABC 5140000JABC 5140000HABC € PIECES/BOX 1 1 1 SUPPORT FOR MODULAR MANIFOLDS • 2 units per bag. DESCRIPTION ARTICLE PIECES/BOX - E-23149 15 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com 37 UNDERFLOOR HEATING/COOLING DISTRIBUTION UNITS FOR COMBINED UNDERFLOOR HEATING/COOLING INSTALLATIONS AND RADIATORS Both high and low temperature channels are obtained from the same distribution unit. It is used when part of the installation requires underfloor heating and the rest of the installation is equipped with radiators. All the components are ready-assembled and factory-tested: all that needs to be done is to connect the pipes. 38 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling DISTRIBUTION UNITS FOR COMBINED UNDERFLOOR HEATING/COOLING INSTALLATIONS AND RADIATORS COMBINED SINGLE POINT DISTRIBUTION UNITS WITH LOCKSHIELDS COMBINED SINGLE POINT DISTRIBUTION UNITS WITH FLOW REGULATORS Components include: 1 manifold with thermostatic valves, 1 Components include: 1 manifold with thermostatic valves, 1 manifold with lockshields, 2 drain valves, 2 supports, 2 drain valves manifold with flow regulators, 2 drain valves, 2 supports, 2 drain with filters, 1 thermostatic mixing valve, 1 pump, 1 differential valves with filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure valve, 2 shut-off valves, Two 2-channel manifolds for pressure valve, 2 shut-off valves, two 2-channel manifolds and a radiators and a metal cabinet. metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency • Note: High-efficiency pumps with a variable flow. ARTICLE PIECES/BOX 42AC1AAHB000 42BC1AAHB000 42CC1AAHB000 42DC1AAHC000 42EC1AAHC000 42FC1AAHC000 42GC1AAHD000 42HC1AAHD000 42IC1AAHD000 42JC1AAHL000 42KC1AAHL000 42AC1ABHB000 42BC1ABHB000 42CC1ABHB000 42DC1ABHC000 42EC1ABHC000 42FC1ABHC000 42GC1ABHD000 42HC1ABHD000 42IC1ABHD000 42JC1ABHL000 42KC1ABHL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE PIECES/BOX 42AD1AAHB000 42BD1AAHB000 42CD1AAHB000 42DD1AAHC000 42ED1AAHC000 42FD1AAHC000 42GD1AAHD000 42HD1AAHD000 42ID1AAHD000 42JD1AAHL000 42KD1AAHL000 42AD1ABHB000 42BD1ABHB000 42CD1ABHB000 42DD1ABHC000 42ED1ABHC000 42FD1ABHC000 42GD1ABHD000 42HD1ABHD000 42ID1ABHD000 42JD1ABHL000 42KD1ABHL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 39 UNDERFLOOR HEATING/COOLING COMPONENTS COUPLING TO PIPE ACCESSORIES Male connection for multilayer pipe Don’t take chances with accessories! • Cap with seals, O-ring, ring and nut. • Featuring two units for each group. new • Greater closing surface with a double seal • Reduces the chance of leaks by 80% • New design DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø16x2 V-01030 30 € Male connection for PER • Cap, O-ring, ring and nut. • Featuring two units per each group. Male connection for multi-layer pipe DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø16x1,5 M24x1,5 Ø16x1,8 M24x1,5 Ø20x1,9 E-13679 E-15700 E-18873 40 40 40 € DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø16x2 M24x1,5 Ø20x2 E-13727 E-13670 40 40 € Note: Same discount as valves and fittings for radiators. INSULATION PANEL ACCESSORIES Staple for castellated panel DESCRIPTION Polypropylene staple for Ø16 and Ø20 mm tube Staple for plain panel ARTICLE UNITS/BAG €/UD. SRCLIP-T 50 DESCRIPTION Polypropylene staple for Ø16 and Ø20 mm tube ADDITIVE FOR MORTAR ARTICLE SRCLIP-L UNITS/BAG €/UD. 50 FLANKING STRIP Polyethylene foam flanking strip • Thickness: 7mm. • Density: 33 kg/m3. 40 DESCRIPTION ARTICLE KG./DRUM Super plasticising additive SRADIT 25 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 €/KG. www.orkli.com DESCRIPTION Without self-adhesive backing With self-adhesive backing Strip with flap and adhesive ARTICLE M./ROLL SRBAN-1 SRBAN-2 SRBAN-3 50 50 50 €/M. oor 01 Underfl Heating/Cooling COMPONENTS ANTI-MOISTURE BARRIER GUIDE ELBOW DESCRIPTION DESCRIPTION ARTICLE Polyethylene film (1 m. width) SRFILM M./COIL €/M. ARTICLE Ø16 mm. Ø20 mm. 200 SRGUIA16 SRGUIA20 PIECES/BOX €/UD. 1 1 EXPANSION JOINTS DESCRIPTION ARTICLE M./BOX SRJUNT-R 50 DESCRIPTION ARTICLE PIECES/BOX Staple Gun SRGRAP Joint (2 m./pieces) €/M. TOOLS Uncoiler Staple Gun DESCRIPTION ARTICLE PIECES/BOX Uncoiler up to rolls of 600 meters SRDESB 1 € Pipe-cutting scissors for PEX-PP-PE and PB pipes of up to 26 mm diameter DESCRIPTION ARTICLE PIECES/BOX Pipe cutting scissors SRCUT 1 € € 1 Fixing rail for multilayer panel DESCRIPTION Rail for Ø 16 tube Rail for Ø 20 tube Tel.: +34 943 80 94 80 ARTICLE M/RAIL SRCAR16-L SRCAR20-L 2 2 Fax: +34 943 80 52 41 €/M. www.orkli.com 41 UNDERFLOOR HEATING/COOLING COMPONENTS FOR CONTROL MIXING VALVES Thermostatic mixing valves for underfloor heating Motorised head for mixing valve DESCRIPTION ARTICLE PIECES/BOX 3/4" female inlet - 1" male outlet E-19813 1 € DESCRIPTION ARTICLE PIECES/BOX 230V - 5Nm - 60" E-18683 1 DESCRIPTION ARTICLE PIECES/BOX 3 ways 3/4" 3 ways 1" 3 ways 1 ½” 3 ways 2” E-18382 E-18680 E-19792 E-19258 1 1 1 1 DESCRIPTION ARTICLE PIECES/BOX Ambient thermostat - ON/OFF Summer - winter ambient thermostat 547005 547006 40 40 € Mixing valve € ROOM THERMOSTATS AND CHRONOTHERMOSTATS Digital Mechanical • Screen indicating room temperature • Temperature adjustable from 0-30ºC. and set temperature. • Ready for fixing on the wall. • Temperature adjustable from 5º - 35ºC. • Powered by two alkaline batteries (1,5 V type LR6) (included). • Low battery indicator. • Ready for fixing on the wall. DESCRIPTION ARTICLE PIECES/BOX Ambient thermostat - ON/OFF Summer - winter ambient thermostat 547000 547001 40 40 € € CS7 series SR series • Temperature adjustable form 5º - 30ºC. • Connections unit: for connection of thermoelectric heads and pump. • Swing 0,5 ºC. • Powered by two alkaline batteries (1,5V type LR6) (included). • Ready for fixing on the wall. 42 DESCRIPTION ARTICLE PIECES/BOX Weekly chronothermostat 579000 - Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com DESCRIPTION ARTICLE PIECES/BOX Connection box Thermostat Cover for public spaces E-25228 E-25229 E-25601 1 1 1 € oor 01 Underfl Heating/Cooling COMPONENTS FOR CONTROL ROOM THERMOSTATS AND CHRONOTHERMOSTATS BY RADIO FREQUENCY CS7 series SR series • Temperature adjustable form 5º - 30ºC. • Connections unit: for connection of thermoelectric heads and pump. • Swing 0,5 ºC. • Powered by two alkaline batteries (1,5V type LR6) (included). • Ready for fixing on the wall. DESCRIPTION ARTICLE PIECES/BOX Weekly chronothermostat + radio receiver kit 578155 5 € DESCRIPTION ARTICLE PIECES/BOX Radio frequency connection box Radio frequency thermostat Cover for public spaces E-25230 E-25231 E-25601 1 1 1 DESCRIPTION ARTICLE PIECES/BOX 2 meters, IP65-NTC 1% - 10K OHM-25ºC E-18901 1 DESCRIPTION ARTICLE PIECES/BOX Thermosound TRP 150 Ø 6,5 x 36 mm. - wire 2 m. E-19452 1 DESCRIPTION ARTICLE PIECES/BOX To prevent steam E-22106 1 € EXTERNAL CLIMATE CONTROL Central heating unit External sensor • Includes card and wall assembly case. DESCRIPTION ARTICLE PIECES/BOX Digital station with more than 1 circuit control Digital station unit with control of central heating/cooling 588253 588252 1 1 € Pocket for pulse sensor € Pulse sensor • Also valid for the return. DESCRIPTION ARTICLE PIECES/BOX Ø 7 x 8 x47, nut 1/2" NPT 555001 1 € Ambient sensor € Anti-steam sensor DESCRIPTION ARTICLE PIECES/BOX Enclosure IP20, Sensor NTC 1% - 10K OHM - 25ºC 576808 1 did you know...? € € Relay module for dehumidifier control A dehumidifier can be controlled via the central regulation unit by fitting this accessory. DESCRIPTION ARTICLE PIECES/BOX Relay module for dehumidifier control E-24593 1 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com 43 UNDERFLOOR HEATING/COOLING COMPONENTS FOR CONTROL THERMOCYCLIC CONTROL did you know...? Is the thermocyclic regulation of an indoor room based on a totally new regulation process? It calculates in advance when the actuator or heater should be switched on or off using a totally new, unique regulation process that learns the properties of each heating system in order to anticipate them and use them for its calculations. The system begins to learn from the first time it is switched on, to provide maximum comfort in every area and every room. It was patented on 27 January 2000 and successfully introduced in the European market. The tests carried out at the Institute of Thermodynamics and Technical Equipment for Buildings of the Dresden University of Technology were confirmed in practice: the energy savings were greater than with traditional thermostat regulation. By means of microoscillations of ± 0.15 ºC, the regulator rapidly configures the desired indoor temperature. white: Theoretical temperature yellow: Real temperature red: Heating switched on. And how does it actually work? In a room with doors and windows and with people inside it, it is almost impossible for a constant temperature to be maintained. Energy is continually supplied and lost: the doors and windows are opened and closed, people enter and leave the room, heaters are switched on or candles are lit, the sun shines through the windows or it rains. The real indoor temperature varies continually: it is not stable. The daily heating phases intensify these temperature oscillations, often by several degrees. This inevitably gives rise to an unpleasant ambient temperature. On the other hand, these temperature changes contain information on the system constants and the atmospheric conditions (the orientation of the room, climate, use). This is how the thermocyclic regulation makes its calculations: it uses this information and controls the oscillations to very fine values. It continually evaluates the movements it has learnt and defined, and then regulates them in real time. The user configures the desired comfort temperature using the central control unit or the interior units, decides how long the night period will last or how the system will be used during the weekend, and the regulation process is performed on the basis of these. No further configuration is necessary. 44 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling COMPONENTS FOR CONTROL THERMOCYCLIC CONTROL DESCRIPTION ARTICLE PIECES/BOX Central unit E-18650 1 DESCRIPTION ARTICLE PIECES/BOX Local unit RS E-18652 1 DESCRIPTION ARTICLE PIECES/BOX Regulator VR E-18654 1 DESCRIPTION ARTICLE PIECES/BOX Wireless ambient temperature sensor E-24872 1 € € € € DESCRIPTION ARTICLE PIECES/BOX Chronothermostats RG E-18651 1 DESCRIPTION ARTICLE PIECES/BOX Switch 4 channels ST E-18653 1 DESCRIPTION ARTICLE PIECES/BOX Transformer TR E-18655 1 DESCRIPTION ARTICLE PIECES/BOX Wireless receiver E-24873 1 DESCRIPTION ARTICLE PIECES/BOX TCS safety contact thermostat 543461 50 DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" E-18603 E-18604 15 10 € € € € CLIMATE CONTROL ACCESSORIES Thermoelectric head Safety contact thermostat • Easy to install: first screw the nut onto the valve, and then screw on the head until you hear a click. The cable does not obstruct assembly. DESCRIPTION NC 220V head M28x1,5 NC 24V head M28x1,5 NC 230V head with micro M30x1,5 NC 230V head ARTICLE F-9996 E-16898 E-18127 CT410800 PIECES/BOX € € 24 24 24 24 Note: Same discount as climate control section. Differential pressure valve improvements Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 45 PROJECT SERVICE IS STANDARD FOR THE SPANISH AND FRENCH MARKET. UNE EN 1264-COMPLIANT PROJECT WITH INSTALLER ASSISTANCE SERVICE Orkli provides a FREE Installer Assistance Service for the works if the complete installation is made using Orkli materials. This service shows installers how to correctly make the installations, to obtain an efficient installation. This service may include a technician visit. Our aim is to guarantee the efficiency of all Orkli Underfloor Heating/Cooling installations, and as part of this commitment we issue a COVERAGE CERTIFICATE for all installations requiring this certification when the installation has been made in accordance with our process and assembly procedure. To request this service, simply indicate this fact along with your order, or call us on 902 19 47 55 46 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling GENERAL CONDITIONS > OFFER VALIDITY PERIOD 90 calendar days from the project delivery date. > OFFER MODIFICATION This estimate will be valid providing the specifications agreed on with the customer are not altered. Any modification made after delivery of the project will entail review of the offer and project. > SUPPLY CONDITIONS The transport will be at the expense of Orkli S.Coop, for all complete underfloor heating orders supplied in one single delivery and exceeding a net price of 900 €. A complete order is taken to mean the purchase of the totality of the underfloor heating and regulation components that figure in Orkli S.Coop.’s estimate. > PRICES The prices are retail prices. The discount agreed on with Orkli S.Coop will be applied in each case. > OFFERS Different estimates will be delivered with each project. A combination of the different estimates may be made in accordance with the customer’s requirements. > CONDITIONS OF THE OFFER This is an offer for the supply of products. It is based on the project drawn up by Orkli S.Coop on the basis of information provided by the customer, and on the exclusive use of Orkli products. If Orkli does not have sufficient information to draw up the projects, they reserve the right to make hypothetical projects. If the customer does not indicate that the data are erroneous, Orkli will presume them to be correct. Orkli shall not be held liable for any damages arising from: > Failure to comply with the specifications indicated in the technical documentation supplied by Orkli S.Coop. > The total or partial use of products other than Orkli S.Coop products. > The incorrect or inappropriate handling, use, conservation or maintenance of the products manufactured and supplied by Orkli S.Coop. > The installation failure of the products. > The data supplied by the customer not being confirmed or being erroneous, incorrect or incomplete. If the offer is accepted, Orkli S.Coop shall only be liable as a supplier of its own products. January 2012 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 47 COVERAGE CERTIFICATE ORKLI S. COOP. has contracted a product liability insurance policy guaranteeing up to: 2 MILLION EUROS and for a period of: 15 YEARS any damages caused by the use of the system products (Basic-16, Basic-20, Mini-16 and Mini-20) attributable to: >Product manufacturing defects. >Defects in the concept or design of the product This certificate will not be valid in the following cases: > Failure to comply with the specifications indicated in the technical documentation supplied by Orkli S. Coop. > Incorrect or inappropriate handling, use, conservation or maintenance of the products manufactured and supplied by Orkli S. Coop. > Any damages deriving from the installation of failure the products. > The data supplied by the customer not being confirmed or being erroneous, incorrect or incomplete. > Products other than Orkli products being used in the installation. IMPORTANT: This guarantee certificate is valid for complete systems only (design, technical assistance service, etc.) offered by Orkli, S. Coop. 48 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com oor 01 Underfl Heating/Cooling HYDRAULIC CHARACTERISTICS Pump RS 25/6 3 Flow height [m] 6 5,6 5,2 4,8 4,4 4 máx. 3,6 3,2 2,8 2,4 m ín. má x. 2 1,6 1,2 0,8 0,4 mín . Pump STRATOS PICO 25/1-6 Δp-c 6 6 5 5 4 4 H [m] H [m] Δp-v 3 3 2 2 1 1 0 0 0 1 2 3 4 0 Q [m3/h] 1 2 3 4 Q [m3/h] Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 49 HYDRAULIC CHARACTERISTICS Cross-linked polyethylene tube using the peroxide method (PEX-A) and multilayer pipe Water temperature 70ºC l/s 100 10 m 0m 0x1 11 2 , x8 90 9 x6, 75 5,8 x 63 6 x4, 50 1 12,0 10,0 7 x3, 40 0 x3, 32 4,0 3 x2, 25 0 x2, 20 0.1 0 x2, 16 0,2 0,25 0,3 0,4 0,5 1,0 1,5 1,25 2,0 1,75 2,5 5,0 6,0 7,0 3,0 m/s 0,6 0.01 kPa/m 0.01 0.1 1 10 100 Mixing valves thermostatics 3 Pressure drop (bar) 2,5 2 1,5 1 0,5 0 0 10 20 30 40 50 60 70 Flow (l/min) 50 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com Correction factor for other temperatures Temperature ºC 90 80 70 60 50 40 30 20 10 Factor 0.95 0.98 1.00 1.02 1.05 1.10 1.14 1.20 1.25 oor 01 Underfl Heating/Cooling HYDRAULIC CHARACTERISTICS Mixing valves Flow l/s m3/h 20 10ºC Δt = 5ºC 40 2" 15ºC 20ºC 30ºC 40ºC 50 10 20 Kvs [m3/h] 7.5ºC 5 25 1 1/2" 10 1" 6.3 3/4" 10 2 5 2 1 0,5 1 0,2 0.5 0,1 0.2 0,05 5 10 20 50 100 500 1 2 5 10 20 50 100 200 Pressure drop ΔP [kPa] Power [kW] Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 51 Underfloor heating/cooling distribution equipment Modular manifolds Modular manifolds with brass male quick couplers Distribution units for combined underfloor heating/cooling installations and radiators Radiators distribution equipment Domestic water distribution equipment Components for distribution equipment Coupling to pipe accessories Manifolds and Manifolds and distribution equipment 02 distribution equipment 02 MANIFOLDS AND DISTRIBUTION EQUIPMENT UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT SINGLE POINT AND VARIABLE POINT DISTRIBUTION UNITS The single point and variable point distribution units are designed to provide professionals with products that will help them carry out their projects, notably improving the quality of the final installation. We have carefully designed this product down to the last detail to make it a competitive solution and so that it really is “all advantages”: safety and reliability, savings on materials and labour costs and quick and easy installation, resulting in a fullyguaranteed product. . in June le b a il a v A 54 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT • Components include: manifold with thermostatic valves, manifold • Components include: manifold with thermostatic valves, manifold with lockshields, 2 drain valves, 2 supports, 2 drain valves with with flow regulators, 2 drain valves, 2 supports, 2 drain valves with filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure valve, 2 shut-off valves and a metal cabinet. valve, 2 shut-off valves and a metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency Manifolds and SINGLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS 02 distribution equipment SINGLE POINT DISTRIBUTION UNIT WITH LOCKSHIELDS • Note: High-efficiency pumps with a variable flow. ARTICLE PIECES/BOX 42AC1AAAB000 42BC1AAAB000 42CC1AAAB000 42DC1AAAC000 42EC1AAAC000 42FC1AAAC000 42GC1AAAD000 42HC1AAAD000 42IC1AAAD000 42JC1AAAL000 42KC1AAAL000 42AC1ABAB000 42BC1ABAB000 42CC1ABAB000 42DC1ABAC000 42EC1ABAC000 42FC1ABAC000 42GC1ABAD000 42HC1ABAD000 42IC1ABAD000 42JC1ABAL000 42KC1ABAL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE PIECES/BOX 42AD1AAAB000 42BD1AAAB000 42CD1AAAB000 42DD1AAAC000 42ED1AAAC000 42FD1AAAC000 42GD1AAAD000 42HD1AAAD000 42ID1AAAD000 42JD1AAAL000 42KD1AAAL000 42AD1ABAB000 42BD1ABAB000 42CD1ABAB000 42DD1ABAC000 42ED1ABAC000 42FD1ABAC000 42GD1ABAD000 42HD1ABAD000 42ID1ABAD000 42JD1ABAL000 42KD1ABAL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 55 MANIFOLDS AND DISTRIBUTION EQUIPMENT UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT VARIABLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS FOR HEATING • Components include: manifold with thermostatic valves, manifold • Components include: manifold with thermostatic valves, manifold with flow regulators, 2 drain valves, 2 supports, 2 drain valves with with flow regulators, 2 drain valves, 2 supports, 2 drain valves with filters, 1 motorised mixing valve, 1 pump, 1 differential pressure filters, 1 motorised mixing valve, 1 pump, 1 differential pressure valve, 1 flow sensor, 1 central regulating unit for heating, 1 external valve, 1 flow sensor, 1 central regulation unit for heating and cooling, sensor, 1 ambient temperature sensor, 2 shut-off valves and a metal 1 external sensor, 1 condensation sensor, 2 shut-off valves and a cabinet. metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE • Note: High-efficiency pumps with a variable flow. PIECES/BOX 42AD1AABB000 42BD1AABB000 42CD1AABB000 42DD1AABC000 42ED1AABC000 42FD1AABC000 42GD1AABD000 42HD1AABD000 42ID1AABD000 42JD1AABL000 42KD1AABL000 42AD1ABBB000 42BD1ABBB000 42CD1ABBB000 42DD1ABBC000 42ED1ABBC000 42FD1ABBC000 42GD1ABBD000 42HD1ABBD000 42ID1ABBD000 42JD1ABBL000 42KD1ABBL000 € 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency Note: Any non included reference in the catalogue, request delivery delay. 56 VARIABLE POINT DISTRIBUTION UNIT WITH FLOW REGULATORS FOR HEATING AND COOLING www.orkli.com ARTICLE PIECES/BOX 42AD1AACB000 42BD1AACB000 42CD1AACB000 42DD1AACC000 42ED1AACC000 42FD1AACC000 42GD1AACD000 42HD1AACD000 42ID1AACD000 42JD1AACL000 42KD1AACL000 42AD1ABCB000 42BD1ABCB000 42CD1ABCB000 42DD1ABCC000 42ED1ABCC000 42FD1ABCC000 42GD1ABCD000 42HD1ABCD000 42ID1ABCD000 42JD1ABCL000 42KD1ABCL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT 02 distribution equipment Manifolds and DISTRIBUTION UNITS WITH PRE-MOUNTED MODULAR MANIFOLDS did you know...? that they prevent condensation in underfloor cooling systems? • The components are easily removable for repair. • Outlet thread: M24x1,5. • Other combinations, upon request. • 3/4" Euroconus, upon request. DESCRIPTION 1" ARTICLE 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways PIECES/BOX 5290552M 5390552M 5490552M 5590552M 5690552M 5790552M 5890552M 5990552M 6090552M 6190552M 6290552M € 1 1 1 1 1 1 1 1 1 1 1 Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 57 MANIFOLDS AND DISTRIBUTION EQUIPMENT UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT DISTRIBUTION EQUIPMENT WITH LOCKSHIELDS • The components are easily removable for repair. • The components are easily removable for repair. • Standpipe entry can easily be changed from left to right or vice • Standpipe entry can easily be changed from left to right or vice versa. versa. • Drain valve replaceable with no need to drain installation. • Drain valve replaceable with no need to drain installation. • A manometer may be fitted. • A manometer may be fitted. • Filters to prevent dirt from entering the • Filters to prevent dirt from entering the installation. installation. • The drain valve may be fitted in various positions, so that the manifold • The drain valve may be fitted in various positions, so that the can be fitted as required. manifold can be fitted as required. • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2,5 € to install the manifold in the box. (See page 85). • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Add 2% for nickel plated manifolds and "N" to the article reference. reference). • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Other combinations, upon request. reference). • Other combinations, upon request. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3280442 3380442 3480442 3580442 3680442 3780442 3880442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5280552 5380552 5480552 5580552 5680552 5780552 5880552 5980552 6080552 6180552 6280552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8280662 8380662 8480662 8580662 8680662 8780662 8880662 8980662 9080662 9180662 9280662 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. 58 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3285442 3385442 3486442 3586442 3686442 3787442 3887442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5285552 5385552 5486552 5586552 5686552 5787552 5887552 5987552 6088552 6188552 6288552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8285662 8385662 8486662 8586662 8686662 8787662 8887662 8987662 9088662 9188662 9288662 1 1 1 1 1 1 1 1 1 1 1 € • The components are easily removable for repair. • The components are easily removable for repair. • Standpipe entry can easily be changed from left to right or vice versa. • Standpipe entry can easily be changed from left to right or vice versa. • Drain valve replaceable with no need to drain installation. • Drain valve replaceable with no need to drain installation. • A manometer may be fitted. • A manometer may be fitted. • Filters to prevent dirt from entering the • Filters to prevent dirt from entering the installation. installation. • The drain valve may be fitted in various positions, so that the manifold • The drain valve may be fitted in various positions, so that the manifold can be fitted as required. can be fitted as required. • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). reference). • Other combinations, upon request. DESCRIPTION • Other combinations, upon request. ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3290442 3390442 3490442 3590442 3690442 3790442 3890442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5290552 5390552 5490552 5590552 5690552 5790552 5890552 5990552 6090552 6190552 6290552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8290662 8390662 8490662 8590662 8690662 8790662 8890662 8990662 9090662 9190662 9290662 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3295442 3395442 3496442 3596442 3696442 3797442 3897442 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5295552 5395552 5496552 5596552 5696552 5797552 5897552 5997552 6098552 6198552 6298552 1 1 1 1 1 1 1 1 1 1 1 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8295662 8395662 8496662 8596662 8696662 8797662 8897662 8997662 9098662 9198662 9298662 1 1 1 1 1 1 1 1 1 1 1 € Note: In modular manifolds and distribution equipment with lockshields, same discount as manifolds and distribution equipment section. Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 59 02 distribution equipment DISTRIBUTION UNITS WITH FLOW REGULATORS Manifolds and UNDERFLOOR HEATING/COOLING DISTRIBUTION EQUIPMENT MANIFOLDS AND DISTRIBUTION EQUIPMENT did you know….? using Modular Manifolds is childsplay? Advantages - better service, less stock. - cleanliness: thanks to their inner sealing gasket which prevents dirt from entering. - greater product reliability. Preparing the manifold 5 4 3 2 1 1 2 The installation of the manifold starts by joining the modules together manually, making the short male connector on one of the modules coincide with the short female connector on the other. Once the modules have been joined, you have to turn one module with-in the other as far as it will go. 3 4 Once all the modules have been installed you need to fit the final module with the purging device and the drain valve following the same process as above. 60 Tel.: +34 943 80 94 80 To finish, make sure that one part no longer turns with-in the other, pushing the safety element with the help of a tool. Carry out these steps with as many modules as necessary. 5 Then install the initial module. Fax: +34 943 80 52 41 www.orkli.com The ball valve will be the last element to be connected. 02 distribution equipment Example: 3-way unit with lockshields fitted SHUT-OFF VALVE INITIAL MODULE INTERMEDIATE MODULE FINAL MODULE Example: 3-way unit with flow regulator fitted Manifolds and Option diagram Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 61 MANIFOLDS AND DISTRIBUTION EQUIPMENT MODULAR MANIFOLDS did you know...? that a fixing support must be included for every 4 modules? START MODULE Start module Shut-off valve DESCRIPTION ARTICLE PIECES/BOX Start module E-26795 1 € DESCRIPTION ARTICLE PIECES/BOX 1" Shut-off valve for impulse without thermometer 1" Shut-off valve for impulse with thermometer 1" Shut-off valve for return without thermometer 1" Shut-off valve for return with thermometer E-23147 E-23148 E-25232 E-25233 24 24 24 24 ARTICLE PIECES/BOX € INTERMEDIATE MODULES Module with M28x1,5 thermostatic valve DESCRIPTION Module with flow regulator ARTICLE 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus PIECES/BOX 5140000 5140000J 5140000H € 1 1 1 DESCRIPTION 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus 5130000 5130000J 5130000H € 1 1 1 Module with lockshield DESCRIPTION 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus 62 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com ARTICLE 5120000 5120000J 5120000H PIECES/BOX 1 1 1 € MODULAR MANIFOLDS End module with thermostatic valve DESCRIPTION ARTICLE PIECES/BOX With drain valve and drain tap E-26796 1 € Outlet thread M24x1,5 DESCRIPTION ARTICLE Outlet thread M24x1,5 End module with flow regulator DESCRIPTION 02 distribution equipment End module Manifolds and END MODULE 5140000MF PIECES/BOX € 1 End module with lockshield ARTICLE 5130000MF PIECES/BOX € 1 DESCRIPTION ARTICLE Outlet thread M24x1,5 5120000MF PIECES/BOX € 1 START/END MODULE Start/end module with drain valve and drain tap Module with M28x1,5 thermostatic valve DESCRIPTION ARTICLE PIECES/BOX Start/end module with drain valve and drain tap E-23146 1 € Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus Module with flow regulator DESCRIPTION DESCRIPTION 5140000B 5140000JB 5140000HB PIECES/BOX € 1 1 1 Module with lockshield ARTICLE 5130000B 5130000JB 5130000HB PIECES/BOX 1 1 1 € DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus Tel.: +34 943 80 94 80 5120000B 5120000JB 5120000HB Fax: +34 943 80 52 41 PIECES/BOX € 1 1 1 www.orkli.com 63 MANIFOLDS AND DISTRIBUTION EQUIPMENT MODULAR MANIFOLDS START/END MODULES + SHUT-OFF VALVE UNIT Start/end module with drain valve and drain tap DESCRIPTION ARTICLE PIECES/BOX Start/end modules + shut-off valve unit E-23145 1 € Module with M28x1,5 thermostatic valve DESCRIPTION Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus DESCRIPTION Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 64 Tel.: +34 943 80 94 80 5140000BC 5140000JBC 5140000HBC PIECES/BOX € 1 1 1 Module with lockshield Module with flow regulator DESCRIPTION ARTICLE ARTICLE PIECES/BOX 5130000BC 5130000JBC 5130000HBC Fax: +34 943 80 52 41 € 1 1 1 www.orkli.com Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus ARTICLE 5120000BC 5120000JBC 5120000HBC PIECES/BOX 1 1 1 € MODULAR MANIFOLDS 1” manifold. Outlet thread M24x1,5 1” manifold. Outlet thread 1/2" 1” manifold. Outlet thread 3/4" Euroconus 02 distribution equipment Module with M30x1,5 thermostatic valve Module with M30x1,5 thermostatic valve DESCRIPTION Manifolds and M30 X 1,5 MODULES ARTICLE 5140000A 5140000JA 5140000HA PIECES/BOX 1 1 1 € DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 5140000AB 5140000JAB 5140000HAB € PIECES/BOX 1 1 1 Module with M30x1,5 thermostatic valve DESCRIPTION ARTICLE Outlet thread M24x1,5 Outlet thread 1/2" Outlet thread 3/4" Euroconus 5140000ABC 5140000JABC 5140000HABC € PIECES/BOX 1 1 1 SUPPORT FOR MODULAR MANIFOLDS • 2 units per bag. DESCRIPTION ARTICLE PIECES/BOX - E-23149 15 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com 65 MANIFOLDS AND DISTRIBUTION EQUIPMENT MODULAR MANIFOLDS WITH BRASS MALE QUICK COUPLERS Over three decades of experience in brass component manufacture allows us to present a product with the highest quality guarantee. Modular manifolds with male quick couplers enable tailor-made installations to be created, and they are easy to install, requiring no special manipulation (Teflon, etc.) and therefore saving on costs. SHUT-OFF VALVE INITIAL MODULE INTERMEDIATE MODULE FINAL MODULE Option diagram 66 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com MODULAR MANIFOLDS WITH BRASS MALE QUICK COUPLERS DESCRIPTION 2 Ways 3 Ways ARTICLE 4200000UR 4300000UR Male quick coupler manifolds with manual valve PIECES/BOX € 1 1 2 Ways 3 Ways ARTICLE 4220000UR 4320000UR PIECES/BOX DESCRIPTION ARTICLE 2 Ways 3 Ways Male quick coupler manifolds with lockshields DESCRIPTION 02 distribution equipment Male quick coupler manifolds Manifolds and • 3/4" M24, distance between outles 36 mm. 4240000UR 4340000UR PIECES/BOX € 1 1 End part € 1 1 First part DESCRIPTION ARTICLE PIECES/BOX Plug Purging device and drain valve Plug with 3/4" thread E-26428 E-26429 E-26431 1 1 1 DESCRIPTION ARTICLE PIECES/BOX 3/4" with red lever 3/4" with blue lever E-26360 E-26361 40 40 € Shut-off valve DESCRIPTION ARTICLE PIECES/BOX First part 3/4" thread female E-26430 1 € Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 67 MANIFOLDS AND DISTRIBUTION EQUIPMENT DISTRIBUTION UNITS FOR COMBINED UNDERFLOOR HEATING/COOLING INSTALLATIONS AND RADIATORS Both high and low temperature channels are obtained from the same distribution unit. It is used when part of the installation requires underfloor heating and the rest of the installation is equipped with radiators. All the components are ready-assembled and factory-tested: all that needs to be done is to connect the pipes. 68 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 02 distribution equipment COMBINED SINGLE POINT DISTRIBUTION UNITS WITH LOCKSHIELDS Manifolds and DISTRIBUTION UNITS FOR COMBINED UNDERFLOOR HEATING/COOLING INSTALLATIONS AND RADIATORS COMBINED SINGLE POINT DISTRIBUTION UNITS WITH FLOW REGULATORS Components include: 1 manifold with thermostatic valves, 1 Components include: 1 manifold with thermostatic valves, 1 manifold with lockshields, 2 drain valves, 2 supports, 2 drain valves manifold with flow regulators, 2 drain valves, 2 supports, 2 drain with filters, 1 thermostatic mixing valve, 1 pump, 1 differential valves with filters, 1 thermostatic mixing valve, 1 pump, 1 differential pressure valve, 2 shut-off valves, Two 2-channel manifolds for pressure valve, 2 shut-off valves, two 2-channel manifolds and a radiators and a metal cabinet. metal cabinet. • Maximum operating temperature: 110ºC. • Maximum operating temperature: 110ºC. • Maximum operating pressure: 6 bar. • Maximum operating pressure: 6 bar. • Connections: 1” female. • Connections: 1” female. • Differential pressure valve scale: 0.2 - 0.6 bar. • Differential pressure valve scale: 0.2 - 0.6 bar. • Mixing valve temperature range: 20ºC-50ºC. • Mixing valve temperature range: 20ºC-50ºC. • Pump characteristics: • Pump characteristics: - Centre distance: 130mm. - Centre distance: 130mm. - Connections: 1 ½”. - Connections: 1 ½”. - RS 25/6-3 pump. - RS 25/6-3 pump. • Note: High-efficiency pumps with a variable flow. DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency • Note: High-efficiency pumps with a variable flow. ARTICLE PIECES/BOX 42AC1AAHB000 42BC1AAHB000 42CC1AAHB000 42DC1AAHC000 42EC1AAHC000 42FC1AAHC000 42GC1AAHD000 42HC1AAHD000 42IC1AAHD000 42JC1AAHL000 42KC1AAHL000 42AC1ABHB000 42BC1ABHB000 42CC1ABHB000 42DC1ABHC000 42EC1ABHC000 42FC1ABHC000 42GC1ABHD000 42HC1ABHD000 42IC1ABHD000 42JC1ABHL000 42KC1ABHL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € DESCRIPTION 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 2 Ways High Efficiency 3 Ways High Efficiency 4 Ways High Efficiency 5 Ways High Efficiency 6 Ways High Efficiency 7 Ways High Efficiency 8 Ways High Efficiency 9 Ways High Efficiency 10 Ways High Efficiency 11 Ways High Efficiency 12 Ways High Efficiency ARTICLE PIECES/BOX 42AD1AAHB000 42BD1AAHB000 42CD1AAHB000 42DD1AAHC000 42ED1AAHC000 42FD1AAHC000 42GD1AAHD000 42HD1AAHD000 42ID1AAHD000 42JD1AAHL000 42KD1AAHL000 42AD1ABHB000 42BD1ABHB000 42CD1ABHB000 42DD1ABHC000 42ED1ABHC000 42FD1ABHC000 42GD1ABHD000 42HD1ABHD000 42ID1ABHD000 42JD1ABHL000 42KD1ABHL000 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 € Note: Any non included reference in the catalogue, request delivery delay. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 69 MANIFOLDS AND DISTRIBUTION EQUIPMENT RADIATORS DISTRIBUTION EQUIPMENT did you know…? radiators can be installed with manifolds? Advantages: • Centralised hydraulics installation. • The installation can be centrally controlled. • “Visible” joints, at specific points, not inside walls, floors, etc. can the installation be made without a valve on the radiator? Advantages: • The installation can be centrally regulated. • No “obstacles”. • It is cleaner. To regulate the temperature of each room, is enough to install a thermostat connected to the manifold thermoelectric head in each one. can the installation be made with two-pipe valves if the radiator has a single-pipe format? Advantages: 70 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 • One single inlet point to the radiator. • The balancing is made from the valve itself. www.orkli.com RADIATORS DISTRIBUTION EQUIPMENT 02 distribution equipment Manifolds and For installations without a valve on the radiator See page 82 DN 10 For two-pipe installations with a single-pipe format DN 10 DN 10 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 71 MANIFOLDS AND DISTRIBUTION EQUIPMENT RADIATORS DISTRIBUTION EQUIPMENT FOR INSTALLATIONS WITH NO VALVE ON THE RADIATOR • Includes: Lockshield, thermoelectric head on each way. • Includes: Lockshield, thermoelectric • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). energy efficiency head on each way. • Components easily removable for repair (O-ring connections). • Outlet thread: M24x1,5. (For Euroconus • Other combinations, upon request. outlet add "H" to the article reference). • Components easily removable for repair (O-ring connections). • Other combinations, upon request. DESCRIPTION 3/4" 1" ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3280040 3380040 3480040 3580040 3680040 3780040 3880040 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 5280050 5380050 5480050 5580050 5680050 5780050 5880050 5980050 6080050 1 1 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 8280060 8380060 8480060 8580060 1 1 1 1 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 8680060 8780060 8880060 8980060 9080060 1 1 1 1 1 € DESCRIPTION ARTICLE 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 1" 5480050U 5580050U 5680050U 5780050U 5880050U 5980050U 6080050U PIECES/BOX € 1 1 1 1 1 1 1 • Includes: Lockshield, thermoelectric head energy efficiency on each way, differential pressure valve, cabinet. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Other combinations, upon request. • Digital thermostat Ref. 547000 not included. 1 1/4" DESCRIPTION 1" 72 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com ARTICLE PIECES/BOX 4 Ways 5 Ways 6 Ways 5486050K 5586050K 5686050K 1 1 1 7 Ways 8 Ways 9 Ways 10 Ways 5787050K 5887050K 5988050K 6088050K 1 1 1 1 € RADIATORS DISTRIBUTION EQUIPMENT 02 distribution equipment Manifolds and FOR INSTALLATIONS WITH NO VALVE ON THE RADIATOR • Includes: Lockshield, thermoelectric head on each way, differential pressure valve, metal cabinet, connections unit by radiofrequency (ref. E-25230). • Thermostat not included. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Other combinations, upon request. energy efficiency DESCRIPTION ARTICLE 4 Ways 5 Ways 6 Ways 1" 5486050AQ 5586050AQ 5686050AQ PIECES/BOX € 1 1 1 MONOTUBE INSTALLATIONS • Outlet thread: M24x1,5. • Outlet thread: M24x1,5. • Other combinations, upon request. • Other combinations, upon request. DESCRIPTION ARTICLE PIECES/BOX € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 4245040P 4345040P 4445040P 1 1 1 3/4" 2 Ways 3 Ways 4 Ways 4205040P 4305040P 4405040P 1 1 1 1" 2 Ways 3 Ways 4 Ways 7245050P 7345050P 7445050P 1 1 1 1" 2 Ways 3 Ways 4 Ways 7205050P 7305050P 7405050P 1 1 1 € Note: The distribution manifolds are supplied pre-assembled and ready to install. For left hand connections, add "I" to the article. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 73 MANIFOLDS AND DISTRIBUTION EQUIPMENT RADIATORS DISTRIBUTION EQUIPMENT MONOTUBE INSTALLATIONS • Metallic inspection box assembled to order. Add 2,5 € to install the manifold in the box. (See page 85). • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Components easily removable for repair (O-ring connections). • Other combinations, upon request. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 3270040 3370040 3470040 1 1 1 1" 2 Ways 3 Ways 4 Ways 5270050 5370050 5470050 1 1 1 1 1/4" 2 Ways 8270060 1 3 Ways 4 Ways 8370060 8470060 1 1 € TWIN PIPE INSTALLATIONS • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Distance between outlets 36 mm. • Other combinations, upon request. • Other combinations, upon request. DESCRIPTION 3/4" 1" reference). • Distance between outlets 36 mm. ARTICLE PIECES/BOX 5 Ways 6 Ways 7 Ways 4506140P 4607140P 4707140P 1 1 1 8 Ways 9 Ways 10 Ways 4807140P 4908140P 5008140P 1 1 1 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 7506250P 7607250P 7707250P 7807250P 7908250P 8008250P 1 1 1 1 1 1 € DESCRIPTION 3/4" 1" ARTICLE 4505040P 4606040P 4706040P 4807040P 4907040P 5007040P 5108040P 5208040P 1 1 1 1 1 1 1 1 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 7505050P 7606050P 7706050P 7807050P 7907050P 8007050P 8108050P 8208050P 1 1 1 1 1 1 1 1 Note: The distribution manifolds are supplied pre-assembled and ready to install. For left hand connections, add "I" to the article. 74 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com PIECES/BOX 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways € RADIATORS DISTRIBUTION EQUIPMENT With lockshields • Outlet thread: M24x1,5. • Outlet thread: M24x1,5. • Distance between outlets 36 mm. • Distance between outlets 36 mm. • Other combinations, upon request. • Other combinations, upon request. DESCRIPTION 3/4" 1" ARTICLE PIECES/BOX 5 Ways 6 Ways 7 Ways 4545040P 4646040P 4746040P 1 1 1 8 Ways 9 Ways 10 Ways 4847040P 4947040P 5047040P 1 1 1 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 7545050P 7646050P 7746050P 7847050P 7947050P 8047050P 1 1 1 1 1 1 € DESCRIPTION 3/4" 1" 02 distribution equipment With manual valves Manifolds and TWIN PIPE INSTALLATIONS ARTICLE PIECES/BOX 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 4525040P 4626040P 4726040P 4827040P 4927040P 5027040P 1 1 1 1 1 1 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 7525050P 7626050P 7726050P 7827050P 7927050P 8027050P 1 1 1 1 1 1 ARTICLE PIECES/BOX 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 4500040 4600040 4700040 4800040 4900040 5000040 5100040 5200040 1 1 1 1 1 1 1 1 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 7500050 7600050 7700050 7800050 7900050 8000050 8100050 8200050 1 1 1 1 1 1 1 1 € • Metallic inspection box assembled to order. DESCRIPTION Add 2,5 € to install the manifold in the box. (See page 85). • Add 2% for nickel plated manifolds and "N" to the article reference. • Outlet thread: M24x1,5. • Distance between outlets 36 mm. • Other combinations, upon request. 3/4" 1" € Note: The distribution manifolds are supplied pre-assembled and ready to install. For left hand connections, add "I" to the article. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 75 MANIFOLDS AND DISTRIBUTION EQUIPMENT DOMESTIC WATER DISTRIBUTION EQUIPMENT • Outlet thread: M24x1,5. • Outlet thread: M24x1,5. • Distance between outlets 36 mm. • Distance between outlets 36 mm. • Other combinations, upon request. • Other combinations, upon request. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways / 3 Ways 4 Ways / 6 Ways E-19869 E-19870 1 1 1" 2 Ways / 3 Ways 4 Ways / 6 Ways E-19871 E-19872 1 1 € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways / 3 Ways 4 Ways / 6 Ways E-19873 E-19874 1 1 1" 2 Ways / 3 Ways 4 Ways / 6 Ways E-19875 E-19876 1 1 Note: The distribution manifolds are supplied pre-assembled and ready to install. For left hand connections, add "I" to the article. 76 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € COMPONENTS FOR DISTRIBUTION EQUIPMENT DESCRIPTION 02 distribution equipment Male manifolds: Ways M24x1,5 Manifolds and MANIFOLDS Male manifolds nickel-plated: Ways M24x1,5 ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 4200000 4300000 4400000 4500000 55 40 30 25 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 1200000 1300000 1400000 1500000 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets € ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 4200000N 4300000N 4400000N 4500000N 55 40 30 25 45 30 25 20 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 1200000N 1300000N 1400000N 1500000N 45 30 25 20 7200000 7300000 7400000 7500000 45 30 25 20 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 7200000N 7300000N 7400000N 7500000N 45 30 25 20 2200000 2300000 2400000 2500000 35 20 15 10 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 2200000N 2300000N 2400000N 2500000N 35 20 15 10 3/4" DESCRIPTION € 3/4" 1" 1" Male manifolds with end plug: Ways 1/2" DESCRIPTION ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 41121 41131 41141 41151 55 40 30 25 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 41124 41134 41144 41154 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets Male manifolds with end plug nickel-plated: Ways 1/2" € DESCRIPTION ARTICLE PIECES/BOX 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 41121N 41131N 41141N 41151N 55 40 30 25 45 30 25 20 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 41124N 41134N 41144N 41154N 45 30 25 20 41221 41231 41241 41251 45 30 25 20 2 Ways 3 Ways 4 Ways 5 Ways 36 mm between outlets 36 mm between outlets 36 mm between outlets 36 mm between outlets 41221N 41231N 41241N 41251N 45 30 25 20 41224 41234 41244 41254 35 20 15 10 2 Ways 3 Ways 4 Ways 5 Ways 50 mm between outlets 50 mm between outlets 50 mm between outlets 50 mm between outlets 41224N 41234N 41244N 41254N 35 20 15 10 3/4" € 3/4" 1" 1" Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 77 MANIFOLDS AND DISTRIBUTION EQUIPMENT COMPONENTS FOR DISTRIBUTION EQUIPMENT MANIFOLDS Male manifolds with manual valve Male manifolds with lockshields • Distance between outlets 36 mm. • Distance between outlets 36 mm. • Outlet thread: M24x1,5. • Outlet thread: M24x1,5. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 4240000 4340000 4440000 60 40 20 1" 2 Ways 3 Ways 4 Ways 7240000 7340000 7440000 60 40 20 1" DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 4220000 4320000 4420000 60 40 20 1" 2 Ways 3 Ways 4 Ways 7220000 7320000 7420000 60 40 20 Male manifolds with manual valve Male manifolds with lockshields • Distance between outlets 36 mm. • Distance between outlets 36 mm. • Outlet thread: 1/2". • Outlet thread: 1/2". DESCRIPTION 3/4" € ARTICLE PIECES/BOX 2 Ways 4240000J 60 3 Ways 4 Ways 4340000J 4440000J 40 20 2 Ways 3 Ways 4 Ways 7240000J 7340000J 7440000J 60 40 20 € DESCRIPTION ARTICLE PIECES/BOX 2 Ways 4220000J 60 3 Ways 4 Ways 4320000J 4420000J 40 20 2 Ways 3 Ways 4 Ways 7220000J 7320000J 7420000J 60 40 20 ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3200000 3300000 3400000 3500000 3600000 3700000 3800000 30 20 15 12 10 9 8 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5200000 5300000 5400000 5500000 5600000 5700000 5800000 5900000 6000000 6100000 6200000 30 20 15 12 10 9 6 6 6 5 5 1 1/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8200000 8300000 8400000 8500000 8600000 8700000 8800000 8900000 9000000 9100000 9200000 20 15 12 9 8 7 7 5 5 4 4 3/4" 1" € € Female manifolds DESCRIPTION • Distance between outlets 50 mm. • Outlet thread: 1/2". • Consult the conditions for 36 and 70 mm, between outlets. 78 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € COMPONENTS FOR DISTRIBUTION EQUIPMENT Female manifold with ADAPTER CONNECTOR MOUNTED Manifolds with THERMOSTATIC VALVES • Distance between outlets 50 mm. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article 02 distribution equipment Manifolds and MANIFOLDS • Distance between outlets 50 mm. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). reference). • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Components easily removable for repair. • Components easily removable for repair. • Protected threads. • Protected threads. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3210000 3310000 3410000 3510000 3610000 3710000 3810000 30 20 15 12 10 9 8 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5210000 5310000 5410000 5510000 5610000 5710000 5810000 5910000 6010000 6110000 6210000 30 20 15 12 10 9 6 6 6 5 5 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8210000 8310000 8410000 8510000 8610000 20 15 12 9 8 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8710000 8810000 8910000 9010000 9110000 9210000 7 7 5 5 4 4 1 1/4" € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3240000 3340000 3440000 3540000 3640000 3740000 3840000 20 15 10 8 6 6 6 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5240000 5340000 5440000 5540000 5640000 5740000 5840000 5940000 6040000 6140000 6240000 20 12 10 8 6 6 6 6 6 5 5 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8240000 8340000 8440000 8540000 8640000 15 10 10 8 6 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8740000 8840000 8940000 9040000 9140000 9240000 6 6 5 5 4 4 1 1/4" Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 79 MANIFOLDS AND DISTRIBUTION EQUIPMENT COMPONENTS FOR DISTRIBUTION EQUIPMENT MANIFOLDS Manifold with LOCKSHIELDS Manifold with FLOW REGULATORS • Distance between outlets 50 mm. • Distance between outlets 50 mm. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Components easily removable for repair. • Components easily removable for repair. • Protected threads. • Protected threads. DESCRIPTION PIECES/BOX 3/4" 3220000 3320000 3420000 3520000 3620000 3720000 3820000 30 20 15 12 10 8 8 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5220000 5320000 5420000 5520000 5620000 5720000 5820000 5920000 6020000 6120000 6220000 20 12 8 6 6 6 6 6 6 5 5 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8220000 8320000 8420000 8520000 8620000 15 10 10 8 6 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8720000 8820000 8920000 9020000 9120000 9220000 6 6 5 5 4 4 1 1/4" 80 ARTICLE 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € DESCRIPTION PIECES/BOX 3/4" 3230000 3330000 3430000 3530000 3630000 3730000 3830000 20 15 10 8 6 6 6 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5230000 5330000 5430000 5530000 5630000 5730000 5830000 5930000 6030000 6130000 6230000 15 10 8 6 6 6 6 6 5 4 4 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8230000 8330000 8430000 8530000 8630000 15 10 8 8 6 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8730000 8830000 8930000 9030000 9130000 9230000 6 5 5 4 3 3 1 1/4" www.orkli.com ARTICLE 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways € COMPONENTS FOR DISTRIBUTION EQUIPMENT Pre-assembled distribution manifolds with FLOW REGULATORS • Distance between outlets 50 mm. • Distance between outlets 50 mm. • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article • Outlet thread: M24x1,5. (For Euroconus outlet add "H" to the article reference). reference). • Add 2% for nickel plated manifolds and "N" to the article reference. • Add 2% for nickel plated manifolds and "N" to the article reference. • Components easily removable for repair. • Components easily removable for repair. DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3280000 3380000 3480000 3580000 3680000 3780000 3880000 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5280000 5380000 5480000 5580000 5680000 5780000 5880000 5980000 6080000 6180000 6280000 1 1 1 1 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8280000 8380000 8480000 8580000 8680000 1 1 1 1 1 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8780000 8880000 8980000 9080000 9180000 9280000 1 1 1 1 1 1 1 1/4" 02 distribution equipment Pre-assembled distribution manifolds with LOCKSHIELDS Manifolds and MANIFOLDS € DESCRIPTION ARTICLE PIECES/BOX 3/4" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 3290000 3390000 3490000 3590000 3690000 3790000 3890000 1 1 1 1 1 1 1 1" 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 5290000 5390000 5490000 5590000 5690000 5790000 5890000 5990000 6090000 6190000 6290000 1 1 1 1 1 1 1 1 1 1 1 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 8290000 8390000 8490000 8590000 8690000 1 1 1 1 1 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 8790000 8890000 8990000 9090000 9190000 9290000 1 1 1 1 1 1 1 1/4" Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 81 MANIFOLDS AND DISTRIBUTION EQUIPMENT COMPONENTS FOR DISTRIBUTION EQUIPMENT ACCESSORIES FOR MANIFOLDS Shut-off valve Shut-off valve with thermometer • Includes nut and sleeve. • Includes nut and sleeve. • Add 2% for nickel plated components and "N" to the article reference. DESCRIPTION 3/4" 1" 1 1/4" ARTICLE PIECES/BOX 1000010 1000020 1000030 40 24 12 € DESCRIPTION 1” valve with red lever 1” valve with blue lever ARTICLE 1000021 1000021MA PIECES/BOX € 24 24 Male end plug • Add 2% for nickel plated components Male end plug with o-ring and "N" to the article reference. • Add 2% for nickel plated components and "N" DESCRIPTION ARTICLE 3/4" 1" 1 1/4" E-16158 E-16159 E-16160 PIECES/BOX € 250 200 120 to the article reference. DESCRIPTION ARTICLE 1" E-18647 Female end plug PIECES/BOX € 200 Accessory for joining the pipe to the radiator with no valve • Add 2% for nickel plated components • Includes nut and hose. and "N" to the article reference. DESCRIPTION ARTICLE 3/4" 1" E-16161 E-16162 PIECES/BOX € 350 200 DESCRIPTION ARTICLE PIECES/BOX 1/2” E-25193 40 DESCRIPTION ARTICLE PIECES/BOX 1" E-18599 15 End unit End unit • Includes purging device and • Includes purging device and drain drain valve. € valve. • Add 2% for nickel plated • No orientation is required as it components and "N" to the article includes a nut and sleeve. reference. DESCRIPTION ARTICLE 1" PIECES/BOX 45200 € 15 Intermediate unit Intermediate unit with thermometer • Includes purging device and • Includes purging device and drain drain valve. valve • Add 2% for nickel plated • Add 2% for nickel plated components components and "N" to the article and "N" to the article reference. reference. 82 DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" 1000100 1000300 15 15 Tel.: +34 943 80 94 80 € Fax: +34 943 80 52 41 € www.orkli.com DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" 1000101 1000301 15 15 € COMPONENTS FOR DISTRIBUTION EQUIPMENT 02 distribution equipment Differential pressure valve Manifolds and ACCESSORIES FOR MANIFOLDS Adapter connector improvements DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" E-18603 E-18604 15 10 € Note: Same discount as valves and fittings radiators section. DESCRIPTION ARTICLE ½” M- Orkli accessory joint M24x1,5 ½” F- Orkli accessory joint M24x1,5 ¾”M- Orkli accessory joint M24x1,5 ¾”F- Orkli accessory joint M24x1,5 M24 • 1,5 x M24 • 1,5 E-13062 E-25169 E-23860 E-25170 E-23859 PIECES/BOX € 300 300 300 300 300 COMPONENTS FOR MANIFOLD OUTLETS Female end plug Thermometer support connector for each outlet DESCRIPTION ARTICLE M24x1,5 E-17984 PIECES/BOX € 350 DESCRIPTION ARTICLE PIECES/BOX M24x1,5 E-16095 15 ARTICLE PIECES/BOX € Thermometer • Case included. DESCRIPTION Working range: 0-60ºC and dial0 35 mm. E-16157 € 80 SUPPORTS Support for FEMALE manifolds Support for MALE manifolds • 2 units per bag. • 2 units per bag. DESCRIPTION ARTICLE PIECES/BOX 3/4" 1" 1 1/4" E-18617 E-18618 E-18619 15 15 15 € DESCRIPTION ARTICLE PIECES/BOX 3/4" 1" E-23159 E-23160 15 15 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 83 MANIFOLDS AND DISTRIBUTION EQUIPMENT COMPONENTS FOR DISTRIBUTION EQUIPMENT MANIFOLD INSPECTION BOXES did you know...? the manifold inspection boxes can be ordered dismantled, so that they take up less space? Our manifold inspection boxes are ready for quick and easy assembly. We supply the boxes folded so that you can assemble them whenever you wish. Indications for choosing the manifold inspection boxes are given below. To choose metallic inspection box according to manifold type, as follows: Ways 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways Inspection box 435 mm. 435 mm. 540 mm. 575 mm. 575 mm. 725 mm. 725 mm. 725 mm. 875 mm. 875 mm. 875 mm. Note: The 4-way modular cabinet measures 575 mm. To choose plastic inspection box for male manifolds for distance between outlets 36 mm, as follows: Ways 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways 11 Ways 12 Ways 84 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 Inspection box 335 mm. 335 mm. 335 mm. 335 mm. 425 mm. 425 mm. 525 mm. 525 mm. 525 mm. 630 mm. 630 mm. www.orkli.com Ways 2 Ways 3 Ways 4 Ways 5 Ways 6 Ways 7 Ways 8 Ways 9 Ways 10 Ways Inspection box 335 mm. 335 mm. 425 mm. 425 mm. 525 mm. 525 mm. 525 mm. 630 mm. 630 mm. Plastic inspection box Metallic inspection box to build in • Supports included. • Cover adjustable between 110 and 150 mm. with lock incorporated. • Steel plate, epoxy painted. • White (RAL 9010), rust-proofed. • Stronger. • Height manifold variable into the inspection box. DESCRIPTION ARTICLE PIECES/BOX 335 x 285 x 86 mm. 425 x 285 x 86 mm. 525 x 285 x 86 mm. 630 x 330 x 86 mm. E-25294 E-25295 E-25296 E-25297 1 1 1 1 € DESCRIPTION 401 x 512 x 105 mm. 540 x 512 x 105 mm. 692 x 512 x 105 mm. 842 x 512 x 105 mm. ARTICLE PIECES/BOX 1005000 1006000 1007000 1008000 1 1 1 1 ARTICLE PIECES/BOX € Metallic inspection box to build in with support • Cover adjustable between 110 and 150 mm. with lock incorporated. • Support adjustable 750-775 mm. • Steel plate, epoxy painted. • White (RAL 9010), rust-proofed. • Stronger. • Height manifold variable into the inspection box. DESCRIPTION 401 x 652 x 105 mm. 540 x 652 x 105 mm. 692 x 652 x 105 mm. 842 x 652 x 105 mm. Tel.: +34 943 80 94 80 1005000R 1006000R 1007000R 1008000R Fax: +34 943 80 52 41 € 1 1 1 1 www.orkli.com 85 02 distribution equipment MANIFOLD INSPECTION BOXES Manifolds and COMPONENTS FOR DISTRIBUTION EQUIPMENT MANIFOLDS AND DISTRIBUTION EQUIPMENT COUPLING TO PIPE ACCESSORIES Male connection for multilayer pipe Don’t take chances with accessories! • Cap with seals, O-ring, ring and nut. • Featuring two units for each group. new • Greater closing surface with a double seal • Reduces the chance of leaks by 80% • New design DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø16x2 V-01030 30 Male connection for PER pipe Male connection for Polybuthilene pipe • Cap, O-ring, ring and nut. • Cap with seals, O-ring, ring and nut. • Featuring two units per each group. • Featuring two units per each group. DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø12x1 M24x1,5 Ø12x2 M24x1,5 Ø14x2 M24x1,5 Ø16x1,5 M24x1,5 Ø16x1,8 M24x1,5 Ø16x1,9 M24x1,5 Ø16x2 M24x1,5 Ø16x2,2 M24x1,5 Ø17x2 M24x1,5 Ø18x2 M24x1,5 Ø18x2,5 M24x1,5 Ø20x1,9 M24x1,5 Ø20x2 M24x1,5 Ø20x3 M24x1,5 Ø20x3,4 E-13676 E-13673 E-13758 E-13679 E-15700 E-18871 E-13768 E-18872 E-13682 E-13780 E-13735 E-18873 E-13787 E-13741 E-13738 40 40 40 40 40 40 40 40 40 40 40 40 40 40 40 € DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø15x1,7 M24x1,5 Ø16x1,8 M24x1,5 Ø20x2,3 E-13816 E-15700 E-19570 40 40 40 € € Male connection for copper pipe • Cap, O-ring, olive and nut. • Featuring two units per each group. Male connection for multilayer pipe DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø12 (red) M24x1,5 Ø14 (green) M24x1,5 Ø15 (brown) M24x1,5 Ø16 (yellow) M26x1,5 Ø18 (white) E-5135 E-5137 E-5139 E-5141 E-5427 40 40 40 40 40 € • Cap with seals, O-ring, ring and nut. • Featuring two units per each group. Male connection for copper pipe • "Fast" nut for copper pipe. • Featuring two units per each group. DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø14x2 M24x1,5 Ø16x2 M24x1,5 Ø16x2,25 M24x1,5 Ø18x2 M24x1,5 Ø20x2 M24x1,5 Ø20x2,25 M24x1,5 Ø20x2,5 M24x1,5 Ø17,5x13 (Gladiator) E-13646 E-13727 E-13637 E-13667 E-13670 E-13643 E-13640 E-13793 40 40 40 40 40 40 40 40 € Note: Same discount as valves and fittings radiators section. 86 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø12 M24x1,5 Ø14 M24x1,5 Ø15 M24x1,5 Ø16 E-14000 E-14001 E-14002 E-14003 80 80 80 80 € 02 distribution equipment Manifolds and HYDRAULIC CHARACTERISTICS Modular manifolds with thermostatic valve 10000 > Open 100% 1504,6 /h d.p. (mmca) 1000 100 10 1000 1554,6 Flow (l/h) Modular manifolds with lockshield 10000 > Open 100% 997,9 /h d.p. (mmca) 1000 100 10 10 100 1047,9 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 87 MANIFOLDS AND DISTRIBUTION EQUIPMENT HYDRAULIC CHARACTERISTICS Modular manifolds with flow regulator 10000 > Open 100% 1008 /h d.p. (mmca) 1000 100 10 10 100 1058 Flow (l/h) Female manifolds with thermostatic valve 10000 Open 1/4 v Open 1/2 v Open 3/4 v d.p. (mmca) 1000 100 10 10 100 Flow (l/h) 88 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 1000 1667,8 317,4 l/h 986,6 l/h 1596,0 l/h HYDRAULIC CHARACTERISTICS 10000 1000 1000 d.p. (mmca) d.p. (mmca) 10000 Manifolds and Female manifolds with lockshield 02 distribution equipment Female manifolds with flow regulator 100 100 10 10 10 100 1000 1614,7 10 Flow (l/h) 726,2 Flow (l/h) Open 3 v Open 4 v Open 1/2 v 109,5 l/h Open total v 201,0 l/h Open total and 1/2 v 610,0 l/h 100 1484,6 l/h 1564,7 l/h Open 1/2 v Open 3/4 v 286,1 l/h 424,3 l/h Open total and 1/4 v 622,7 l/h Open total and 1/2 v 676,2 l/h Male manifolds with manual valves 10000 Open 1/2 v Open total Open total and 1/2 v Open 2 and 1/2 v d.p. (mmca) 1000 471,4 l/h 1203,4 l/h 1688,0 l/h 2618,8 l/h 100 10 100 1000 2668,8 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 89 03 energy efficiency 03 systems Solar heating Solar heating systems Solar system with integrated OKSOL-150 tank Drain-Unit; hydraulic unit with drain-back system Drain-Unit; dual hydraulic unit with drain back system Hydraulic units for major installations Solar hydraulic units high efficiency Hydraulic pumping units with integrated control Hydraulic pumping units without regulation Indirect heat exchange solar kit Solar dhw kit Zone valves Safety valves Flowmeters Safety groups Compensation valves Drain valves/air separators Mixing valves Adjustment for solar heating installations Solar expansion vessels Accessories for expansion vessels SOLAR HEATING SYSTEMS SOLAR SYSTEM WITH INTEGRATED OKSOL-150 TANK OKSOL-150 is an integrated solar collector that uses thermal solar power to produce domestic hot water. The absorber, the forced recirculation system and a DHW storage tank holding 150 litres of water are all included in one single element. It uses photovoltaic solar technology to supply the recirculating pump®, making it a totally independent system with no external power requirements. How does it work? When solar radiation falls on the collector, the collector concentrates the heat and transfers it to the heat-carrying fluid circulating inside it. Its cover shape and selective treatment enable the whole surface of the fluid-filled heat-carrying collector to be made use of. As a result, the solar radiation reaches both the heat-carrying fluid and the photovoltaic panel, which generates electricity, causing the recirculating pump to run and the hot fluid to be conveyed to the inside of the heat exchanger. The heat is transferred from the collector to the tank by means of the pump controlled by the photovoltaic panel and the heat exchanger. On sunny days the tank will heat up to maximum storage temperature of 95ºC. How is it installed? No building work required! Built into a sloping roof. On a flat roof or in a garden. What is it used for? • • • • Heating water for domestic use, showers, washing dishes, washing hands, etc. - Homes, campsites, caravans Leisure parks. Home refurbishment. Rural homes. Advantages over other systems: • • • • • • • 92 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com Sloping roof top structure. 5 years warranty Quick and easy to install: only the water inlet and outlet need to be connected. Independent system: no electricity required. Automatic system: no regulation required. It does not take up space in the home. The tank is installed in the same location as the panel. Similar performance to an element-based system. Fully integrable, stylish modern appearance. Will not rust. Solar heating • • Pump powered by photovoltaic cell. Storage capacity: 150 litres. Useful collection surface area: 1,95 m2. Heat exchanger surface: 0,29 m2. External dimensions: - Length: 2029 mm. - Width: 1020 mm. - Depth: 250 mm. - Empty weight including tank: 80 kg. Structure on ground or flat terrace included. Roof-integrated structure, sloping roof top structure and wall structure, under request. DESCRIPTION ARTICLE PIECES/BOX OKSOL-150 1 DESCRIPTION ARTICLE PIECES/BOX Sloping roof top structure (Non-perforatin anchor kit not included) V-00395 DESCRIPTION ARTICLE Non-perforating anchor kit V-01036 Solar collector with integrated tank 03 systems • • • • • € Keymark Solar Certificate 011-7S1479A. DESCRIPTION ARTICLE Roof-integrated structure V-00397 DESCRIPTION ARTICLE Wall structure V-00396 PIECES/BOX € 1 PIECES/BOX 1 € Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € 1 PIECES/BOX € 1 www.orkli.com 93 SOLAR HEATING SYSTEMS optimise your Solar Power Advantages A solution to prevent overheating and freezing. install your own DRAIN UNIT solution with the DRAIN BACK system The best automatic draining unit on the market! Bigger s g n i v a S select Simopmlpyonents you need all the c ible Compat exchangers , heat llectors he market o c e h t on t with all ulators and reg latiocntorss than l a t s n i lle For er of co mb rger nu natives with a la r market alter othe 94 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com d patente DRAIN UNIT: HYDRAULIC UNIT WITH DRAIN-BACK SYSTEM Height-adaptable for use with lower-powered pumps, which means savings and better overall system efficiency. 5-10 mmetres 10-15 metres RECOMMENDED MODEL 6-metre pumps 6-metre + 6-metre pumps 11 + 6 metre pumps ECONOMY MODEL 6-metre pumps 11-metre pumps Unfit NUMBER OF PLATES** 1-5 1-4 1-4 03 systems Solar heating HEIGHT OF INSTALLATION* 3-5 metres *Height from the top of the solar collectors to the lowest point of the drain unit **Calculated for a collector capacity of 1.25 litres and tube 15 mm. It can be used with installations that have a larger number of collectors than other market alternatives. The volume of the circuit above the drain unit must not exceed 8 litres of the working volume of the air separator. Volume calculation in upper part: Volume = Nº of collectors + Volume of fluid in collector + Volume of pipes DRAIN UNIT WITH INTEGRATED REGULATION • Maximum operating temperature: 110ºC. • Maximum peaks: 130ºC. • Safety valve calibration: 3 bar. • Flow indication range: 2-12 litres/min. • Maximum separation volume: 8 litres. • Connections: bicone nut for a Cu15mm o ½”M pipe. • Control options with pre-connections made. • Consult for adaptability to other regulations. TWO 6-metre PUMPS PUMPS 6 metres + 6 metres 6 metres + 6 metres REGULATION Basic (3 sensors, 1 relay) Vision (6 sensors, 3 relays) ARTICLE € 74110BA 74110VI Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 95 SOLAR HEATING SYSTEMS DRAIN UNIT WITH INTEGRATED REGULATION ONE 11-metre PUMP PUMPS 11 metres 11 metres REGULATION Basic (3 sensors, 1 relay) Vision (6 sensors, 3 relays) ARTICLE € 74200BA 74200VI ONE 6-metre PUMP PUMPS 6 metres 6 metres 96 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 REGULATION Basic (3 sensors, 1 relay) Vision (6 sensors, 3 relays) www.orkli.com ARTICLE 74100BA 74100VI € DRAIN UNIT WITH INTEGRATED REGULATION 03 systems Solar heating TWO 11+6-metre PUMPS PUMPS 11 metres + 6 metres 11 metres + 6 metres REGULATION Basic (3 sensors, 1 relay) Vision (6 sensors, 3 relays) ARTICLE € 74210BA 74210VI DRAIN UNIT WITHOUT REGULATION • Maximum operating temperature: 110ºC. • Maximum peaks: 130ºC. • Safety valve calibration: 3 bar. • Flow indication range: 2-12 litres/min. • Maximum separation volume: 8 litres. • Connections: bicone nut for a Cu15mm o ½”M pipe. • Consult for adaptability to other regulations. PUMPS 6 metres + 6 metres 11 metres 6 metres 11 metres + 6 metres • Recommended characteristics: • Solar regulation with a differential relay. • Maximum temperature function of collector 110ºC. (recommended). • Difference in activation temperature 10-15ºC.(recommended). REGULATION - ARTICLE € 74110 74200 74100 74210 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 97 SOLAR HEATING SYSTEMS DRAIN UNIT: DUAL HYDRAULIC UNIT WITH DRAIN BACK SYSTEM Now for installations with twice as many solar collectors as the existing system. 98 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com DRAIN UNIT: NEW HYDRAULIC UNIT WITH DRAIN BACK SYSTEM • In case of no regulation options, the regulation must comply with the following characteristics: - Solar regulation with a differential relay. - Maximum temperature function of collector 110ºC. (recommended). - Difference in activation temperature 10-15ºC.(recommended). Solar heating • Maximum operating temperature: 110ºC. • Maximum peaks: 130ºC. • Safety valve calibration: 3 bar. • Flow indication range: 2-12 litres/min. • Maximum separation volume: 16 litres. • Connections: bicone nut for a Cu15mm o ½”M pipe. • Control options with pre-connections made. • Consult for adaptability to other regulations. 03 systems ONE 11-metre PUMPS PUMPS 11 metres 11 metres 11 metres REGULATION ARTICLE € Basic (3 sensors, 1 relay) 74200BADO Vision (6 sensors, 3 relays) 74200VIDO NO 74200DO TWO 11+6-metre PUMPS PUMPS 11 metres + 6 metres 11 metres + 6 metres 11 metres + 6 metres REGULATION ARTICLE € Basic (3 sensors, 1 relay) 74210BADO Vision (6 sensors, 3 relays) 74210VIDO NO 74210DO Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 99 SOLAR HEATING SYSTEMS HYDRAULIC UNITS FOR MAJOR INSTALLATIONS FOR COLLECTOR FIELDS OF UP TO 50 M2 SAVINGS! 70% SAVINGS ON LABOUR COSTS FOR COMPONENT INSTALLATION ALL HYDRAULIC COMPONENTS PRE-ASSEMBLED 100 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com HYDRAULIC UNITS FOR MAJOR INSTALLATIONS PUMP Solar heating Maximum operating temperature in flow branch: 160ºC. Maximum temperature in return branch: 110ºC. Maximum temperature of safety valve: 160ºC. Hydraulic unit for collector fields of up to 50 m2. Safety valve calibration: 6 bar. Thermometer temperature range: 0-120ºC. Flow indication range: 5-40l/min. Manometer scale: 0-10 bar. Distance between branches: 125mm. Connections: 1 1/4" for flexible pipe DN25 and bicone nut for a pipe Cu 28mm. Connection for expansion vessel: ¾”M. Consult for adaptability to other regulations. 03 systems • • • • • • • • • • • • PIPE Cu28 JOINT ACCESSORIES TOP S 25-13 (13 metres) TOP S 25-13 (13 metres) NO YES € ARTICLE 75000 75100 HYDRAULIC CHARACTERISTICS Pump Top S-25-13 Flow height (m) 13 12 11 10 9 8 7 m 6 5 4 áx . 3 2 m in. 1 0 0,4 0,8 1,2 1,6 2 2,4 Tel.: +34 943 80 94 80 2,8 3,2 (m3/h) Fax: +34 943 80 52 41 www.orkli.com 101 SOLAR HEATING SYSTEMS SOLAR HYDRAULIC UNITS HIGH EFFICIENCY The optimum efficiency of the sun as a power source The SolarOrkli line opts for technologically innovative products contributing to smarter, more sustainable consumption of renewable energies. An example are the high-efficiency solar hydraulic units, which include components that can increase energy efficiency by almost 50%. 102 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com SOLAR HYDRAULIC UNITS HIGH EFFICIENCY • • • • • • • Pump consumption range: 4-60W. Energy count option on models with electronic sensors. Manometer scale: 0-10 bar. Connections: 3/4"H. Branch distance: 95 mm. Regulation with connections made. EPP insulation. Solar heating Maximum working temperature in flow branch: 120ºC. Maximum working temperature in return branch: 100ºC. Maximum working temperature of safety valve: 160ºC. Safety valve calibration: 6 bar. Thermometer temperature range: 0-120ºC. Flow meter indication range: 2-40 l/min. High energy efficiency pump with cabling preconnection. External PWM pump modulation. Consult for adaptability to other regulations. 03 systems • • • • • • • • • + HYDRAULICS Complete Complete Complete Complete Complete Complete Complete Complete PUMP CLIMATE CONTROL BASIC HE Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM Stratos Tec 15/1-7 PWM ELECTRONIC FLOW TEMPERATURE AND PRESSURE SENSORS YES YES YES YES NO NO NO NO EXPANSION VESSEL JOINT ACCESSORIES YES NO YES NO YES NO YES NO YES YES NO NO YES YES NO NO € ARTICLE 73140BAHE 73100BAHE 73040BAHE 73000BAHE 73140HE 73100HE 73040HE 73000HE HYDRAULIC CHARACTERISTICS Power 7 70 6 60 5 50 4 50% 40% 30% 40 3 30 2 20 1 10 0 Efficiency (%) 80 P1 (W) H (mCE) Head 8 20% 10% 0 0 0,5 1 1,5 2 2,5 3 0% 0 Q (m3/H) 0,5 1 1,5 2 2,5 3 Q (m3/H) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 103 SOLAR HEATING SYSTEMS All the hydraulic components required for a solar installation Air vent valve with ball valve Collectors field Solar hydraulic pump units Solar expansion vessels Swimming pool Zone valve Drain valves with air separators Hot water tank 104 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com Support system Boiler HYDRAULIC PUMPING UNITS WITH INTEGRATED CONTROL Maximum operating temperature in flow branch: 160ºC Maximum operating temperature in return branch: 110ºC. Maximum operating temperature in safety valve: 160ºC. Hydraulic unit for collector fields of up to 16 m2. • • • Safety valve calibration: 6 bar Thermometer temperature range: 0-120ºC. Consult for adaptability to other regulations. • • • • • Flow indication range: 2-12 l/min. Manometer scale: 0-10 bar. Connections: 3/4”H. Distance between branches: 95 mm. Control with connections made. Solar heating • • • • HYDRAULICS FLOW BRANCH 03 systems + PUMP* CLIMATE CONTROL RETURN BRANCH Complete Complete Complete Complete Complete Complete Complete Complete ST 15/6eco ST 15/6eco ST 15/6eco ST 15/6eco EXPANSION VESSEL JOINT ACCESSORIES Basic (3 inputs, 1 relay) Vision (6 inputs, 3 relays) Basic (3 inputs, 1 relay) Vision (6 inputs, 3 relay) NO NO YES YES ARTICLE € 70000BA 70000VI 70100BA 70100VI Note: Consult pump curves. + HYDRAULICS FLOW BRANCH NO NO NO NO PUMP* CLIMATE CONTROL RETURN BRANCH Complete Complete Complete Complete ST 15/6eco ST 15/6eco ST 15/6eco ST 15/6eco EXPANSION VESSEL JOINT ACCESSORIES Basic (3 inputs, 1 relay) Vision (6 inputs, 3 relays) Basic (3 inputs, 1 relay) Vision (6 inputs, 3 relays) NO NO YES YES ARTICLE € 70020BA 70020VI 70120BA 70120VI Note: Consult pump curves. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 105 SOLAR HEATING SYSTEMS HYDRAULIC PUMPING UNITS WITHOUT REGULATION • • • • Maximum operating temperature in flow branch: 160ºC Maximum operating temperature in return branch: 110ºC. Maximum operating temperature in safety valve: 160ºC. Hydraulic unit for collector fields of up to 16 m2. • • Safety valve calibration: 6 bar. Consult for adaptability to other regulations. • • • • • Thermometer temperature range: 0-120ºC. Flow indication range: 2-12 l/min. Manometer scale: 0-10 bar. Connections: 3/4”H. Distance between branches: 95 mm. + HYDRAULICS PUMP* FLOW BRANCH CLIMATE CONTROL RETURN BRANCH Complete Complete Complete Complete ST 15/6eco ST 15/6eco NO NO EXPANSION VESSEL JOINT ACCESSORIES NO YES ARTICLE € 70000 70100 Note: Consult pump curves. + HYDRAULICS FLOW BRANCH No No PUMP* CLIMATE CONTROL RETURN BRANCH Complete Complete ST 15/6eco ST 15/6eco Note: Consult pump curves. 106 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com NO NO EXPANSION VESSEL JOINT ACCESSORIES NO YES ARTICLE 70020 70120 € HYDRAULIC CHARACTERISTICS OF PUMPS ST15/6 ECO 6 03 systems Solar heating 5 Head (m) 4 3 2 1 0 0,5 1 1,5 2 2,5 3 3 Water flow (m3/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 107 SOLAR HEATING SYSTEMS INDIRECT HEAT EXCHANGE SOLAR KIT The indirect heat exchange solar kit is designed for centralised solar heating installations with distributed back-up power. Each home has an individual back-up power source and its own interior distribution circuit supplying domestic water. This kit regulates the recirculation inlet to the home from the circuit previously heated by the solar collector. If the kit detects that a tap has been turned on and hot water is required, the flow to the heat exchanger is opened to preheat the domestic water inlet. When the hot water tap is turned off, the 3-way valve opens the bypass again and shuts off the flow to the heat exchanger. The shut-off valves allow the central recirculation system to be completely blocked off at all the inlets. 108 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com did you know…? 03 systems Solar heating that if you wish you may complete the totally regulated installation with the solar domestic water kit? INDIRECT HEAT EXCHANGE SOLAR KIT • • • • • • • • Fastening template Dimensions: 350 x 308 x 115 mm. Heat exchanger power: 35KW. Activation flow: 2L/min. Maximum HWR operating flow: 15L/min. Maximum heating operating flow: 20L/min. Maximum HWR pressure: 15bar. Maximum heating temperature: 70ºC. Connections: ¾”M. Heat exchanger Heating output Heating input HWR input 3 ways valves HWR output Hydraulic valve DESCRIPTION ARTICLE Solar Kit S40000002 PIECES/BOX € 1 HYDRAULIC CHARACTERISTICS Heating 1000 500 800 400 600 400 300 200 H (m) H (m) Hot water circuit 200 0 100 0 0 200 400 600 800 0 200 400 Flow (L/h) Hot water circuit 600 800 1000 Flow (L/h) Circuit bypass Circuit heat exchanger Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 109 SOLAR HEATING SYSTEMS SOLAR DHW KIT A universal kit for connecting a solar hot water tank to a conventional domestic hot water source Unit for connection to the auxiliary domestic water heating units installed between the solar water tank and this back-up power source, normally an instant water heater or a gas or electric water heater. It includes a 3-way valve, which determines whether the water from the solar water tank should be conveyed via the back-up power source or can be directly sent on for consumption, and a mixing valve regulating the outlet temperature of the domestic hot water in the solar heating + conventional back-up system. Solar hot water tank Domestic hot water outlet From the solar collector field Return to the solar collector field Mains water connection 110 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com Hydraulic diagram: If water in solar hot water tank <48ºC 03 systems Solar heating If water in solar hot water tank >48ºC Domestic hot water outlet Mains water connection Domestic hot water outlet From the solar hot water tank >48ºC From the solar hot water tank <48ºC Mains water connection SOLAR DHW KIT • • • • • • • • • • Valve material: brass, according to EN12165 standard. Closure gasket material: EPDM. Connections: ½”, or 15 mm copper pipes. Maximum operating temperature: 90ºC. Maximum operating pressure: 10 bar. Calibration of 3-way valve/bypass temperature: 48ºC. Bypass temperature tolerance: +-2ºC. Thermostatic mixer regulation range: 30-60ºC. Mixing outlet temperature calibration: 45ºC. Components suitable for use with domestic water. DESCRIPTION Solar dhw kit Tel.: +34 943 80 94 80 ARTICLE S40000001 Fax: +34 943 80 52 41 PIECES/BOX € 1 www.orkli.com 111 SOLAR HEATING SYSTEMS ZONE VALVES • To be used in solar system primary circuits. • Fluid temperature -20ºC - 160ºC. • Fluid: water with glicol up to 50%. • Normally closed in A. 2 ways - Without run-end micro: 3 wires 2 ways - With run-end micro: 5 wires improvements improvements • More robust transmission • More robust transmission DESCRIPTION ARTICLE 1/2" 3/4" 1" PIECES/BOX 30112200 30212200 30312200 € 10 10 10 DESCRIPTION 1/2" 3/4" 1" 3 ways - Without run-end micro: 3 wires improvements • More robust transmission • More robust transmission ARTICLE 1/2" 3/4" 1" PIECES/BOX € 10 10 10 3 ways - With run-end micro: 5 wires improvements DESCRIPTION ARTICLE 30122200 30222200 30322200 PIECES/BOX 40112200 40212200 40312200 € 10 10 10 DESCRIPTION 1/2" 3/4" 1" ARTICLE 40122200 40222200 40322200 PIECES/BOX € 10 10 10 M-M SOLAR ZONE VALVES 2 ways - With run-end micro: 5 wires M-M 2 ways - Without run-end micro: 3 wires M-M improvements improvements • More robust transmission • More robust transmission DESCRIPTION ARTICLE 3/4" 1" PIECES/BOX 30612200 30712200 € DESCRIPTION 1" 10 10 3 ways - Without run-end micro: 3 wires M-M improvements improvements • More robust transmission ARTICLE 3/4" 1" PIECES/BOX 40612200 40712200 € 10 10 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 DESCRIPTION 1" Note: Same discount as zone valves section. 112 PIECES/BOX € 10 3 ways - With run-end micro: 5 wires M-M • More robust transmission DESCRIPTION ARTICLE 30722200 www.orkli.com ARTICLE 40722200 PIECES/BOX 10 € SAFETY VALVES • Safety valve for solar installation primary circuits. • Suitable for working with 50% water-glycol mixture. • Maximum operating temperature: 160ºC. • Solar safety valve certification: TÜV SV 07 2012 • SOL • 50 • Consult for other setting options. PIECES/BOX 50 50 50 50 50 DESCRIPTION ARTICLE PIECES/BOX 3/4" F - 1" F (loose nut) / 2-12 l/m 3/4" F - 1 1/2" F (loose nut) / 2-12 l/m 1 1/4" M - 1 1/2" F (loose nut) / 5-40 l/m E-23045 E-23046 E-25292 1 1 1 ARTICLE PIECES/BOX € Solar heating ARTICLE 17175-00 17176-00 17177-00 17178-00 17179-00 1/2"F - 3/4"F (3 bar) 1/2"F - 3/4"F (4 bar) 1/2"F - 3/4"F (6 bar) 1/2"F - 3/4"F (8 bar) 1/2"F - 3/4"F (10 bar) 03 systems DESCRIPTION Note: Same discount as valves and safety groups section. FLOWMETERS • Flow indication range:5/40 l/m y 2-12 l/m. • Includes: filling/emptying tap. • Maximum operating temperature: 110ºC. • Flow regulation. • Vertical installation. • Suitable for use with 50% water/glycol mix. € SAFETY GROUPS • Set a 7 bar. • Featuring: - Locking tap. • AISI 302 stainless steel valve spring. - Purging or vacuum device. • Chemical-nickel treated brass valve shaft. - Antireturn device. • To be assembled outside. • To be used in solar system primary circuits. • Special plastic omponents for UV rays. Straight orientation DESCRIPTION 3/4" 3/4" with adaptor to 1/2" 24170 24470 € 20 20 Note: Same discount as valves and safety groups section. COMPENSATION VALVES • Designed to work outdoors. • Stainless steel spring. • Plastic lever adapted to resist UV rays. DESCRIPTION 1/2" - 7K 3/4" - 7K Tel.: +34 943 80 94 80 ARTICLE 10576 10577 Fax: +34 943 80 52 41 PIECES/BOX € 120 90 www.orkli.com 113 SOLAR HEATING SYSTEMS DRAIN VALVES/AIR SEPARATORS Automatic drain valve Air separator • Maximum operating temperature 150ºC. • Maximum operating temperature 150ºC. • Suitable for working with water-glycol mixture. • Suitable for working with water-glycol mixture. • Maximum operating pressure 6 bar. • Maximum operating pressure 6 bar. • To be installed in horizontal lines. DESCRIPTION ARTICLE PIECES/BOX 3/8" (to be installed with ball valve) 3/8" air vent valve with ball valve E-22721 E-22722 1 1 € DESCRIPTION ARTICLE PIECES/BOX 3/8” with accessories for 22 mm Cu pipe E-22723 1 € MIXING VALVES Thermostatic mixing valves for domestic water High-temperature thermostatic mixing valves • Include two filters and two antireturns at the • Maximum hot water inlet temperature: 130ºC. inlet and outlet. • Kv 1,5 m3/h. • Specific for solar heating installations. • Kv 1,5 m3/h. DESCRIPTION ARTICLE PIECES/BOX 3/4" M without nuts 3/4" M without nuts 1/2" M without nuts 1/2" H without nuts, 2 ball valves E-19807 E-19808 E-19809 E-19810 1 1 1 1 € DESCRIPTION ARTICLE PIECES/BOX 3/4" M without nuts (30-60ºC) 3/4" M with nuts (30-60ºC) E-22716 E-22717 1 1 DESCRIPTION ARTICLE PIECES/BOX 3 inputs, 1 relay and temperature limitation 6 inputs, 3 relays and temperature limitation E-22724 E-22725 1 1 DESCRIPTION ARTICLE PIECES/BOX 35 liters 50 liters 80 liters E-24891 E-24892 E-24893 1 1 1 € ADJUSTMENT FOR SOLAR HEATING INSTALLATIONS • Controls for solar heating installation primary circuits. • 6 inputs, 3 relays. • Temperature sensors included. Diagrams with: • 3 inputs, 1 relay. - Two collector fields, 2 pumps. - 1 Pump + zone valve; two accumulators. - 1 Pump + zone valve; two collector fields. € SOLAR EXPANSION VESSELS • Maximum operating temperature 130ºC. • Suitable for working with water-glycol mixture. • Connection 3/4”. 114 • Connection 1"M. DESCRIPTION ARTICLE PIECES/BOX 12 liters 18 liters 24 liters E-22726 E-22727 E-22728 1 1 1 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com € ACCESSORIES FOR EXPANSION VESSELS ARTICLE PIECES/BOX 3/4" F connection E-23051 1 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 03 systems DESCRIPTION Solar heating • Includes: Wall fixing plate, 3-piece connector, flexible hose, rawlplugs, screws. 115 04 valves with thermostatic heads WHITHOUT ANY BUILDING WORK Thermostatic head valves Thermostatic valves: bitube, monotube, conecta system Thermostatic unit Special valves for bathrooms: Deluxe series Manual valves: bitube, monotube Lockshields Purging devices Hydraulic modules for radiators with integrated taps Accessories Valves and home refurbishment plan ttings 04 fifor radiators Valves and fittings for radiators VALVES AND FITTINGS FOR RADIATORS home refurbishment plan valves with thermostatic heads energy efficiency SAVINGS AND COMFORT, NO BUILDING WORK REQUIRED For home refurbishments, explain the advantages of installing valves with thermostatic heads to your customer: > easy installation, no building work required. > energy savings: up to 12%. > the temperature of each room is regulated separately. > maximum comfort. 118 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com PRACTICAL cases > INDIVIDUAL AND CENTRALISED BITUBE INSTALLATION: CHANGING THE VALVE AND THE LOCKSHIELD Example of hydraulic connection with zoning with individual boiler. Single family 2 storeys. Earth Ambient thermostat 230V Ambient thermostat ttings 04 fifor radiators Earth Valves and 230V Example of hydraulic connection with central heating and 3-way valves. Earth Ambient thermostat 230V A Earth Ambient thermostat Hot water pipework Cold water return pipe B 230V B A Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 119 valves with thermostatic heads home refurbishment plan WITHOUT ANY BUILDING WORK > INDIVIDUAL AND CENTRALISED BITUBE INSTALLATION: CHANGING THE VALVE AND THE LOCKSHIELD 1 If the valve-radiator distances do not coincide, use the telescopic tail. 3 If when fitting thermostatic valves you notice noises in the installation, you need to reduce the speed of the boiler pump. If the noises persist, you need to fit a differential pressure valve between the delivery and the return, on the boiler outlet. See page 124 4 See page 148 2 If To prevent the thermostatic head from sticking out from the wall more than the radiator, See page 148 when you dismantle the valve you find that the pipes are damaged or too short, use either the nickel-plated extension pipe or the adapter connector. If necessary, you can shorten the pipe more to enable the extension pipe to be fitted. See page 148 Orkli recommends that you fit the interchangeable reverse angle valve. See page 147 If , moreover, you would like to save more on your energy bill, we suggest you fit a wireless programmable chronothermostat that will enable you to switch off your central heating system at the times of day necessary. See page 180 Copper 120 Tel.: +34 943 80 94 80 Per Multi-layer Fax: +34 943 80 52 41 www.orkli.com > INDIVIDUAL AND CENTRALISED MONOTUBE INSTALLATION Example of hydraulic connection with zoning with individual boiler. Single family 2 storeys. Earth Ambient thermostat 230V Earth Valves and ttings 04 fifor radiators Ambient thermostat 230V Example of hydraulic connection with central heating and 3-way valves. Earth Ambient thermostat 230V A Earth Ambient thermostat Hot water pipework Cold water return pipe B 230V B A Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 121 valves with thermostatic heads home refurbishment plan WITHOUT ANY BUILDING WORK > INDIVIDUAL AND CENTRALISED MONOTUBE INSTALLATION 1 2 The extensive range of Orkli monotube valves allows the different existing distances between the valves and the pipes to be absorbed. It is important that the separation probe is inserted as far as possible into the radiator (at least 2/3 of its length). 3 4 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 If any noises are heard, even after having balanced the installation, a differential pressure valve needs to be installed. See page 124 A 122 To optimise the performance of the sheet metal panels, we recommend using the 4-way lockshields, as they allow the water to circulate through the radiator as if it were a bitube installation. www.orkli.com > FOR INSTALLATIONS WITH NO VALVE ON THE RADIATOR did you know…? can the installation be made without a valve on the radiator? Advantages: Valves and ttings 04 fifor radiators • The installation can be centrally regulated. • No “obstacles”. • It is cleaner. See page 82 DN 10 With this distribution equipment it is not necessary to use valves or lockshields on the radiators. To regulate the temperature separately in each room, you just have to fit a thermostat in each room connected to the manifold’s thermoelectric head. The distribution manifold equipment includes: Lockshield, thermoelectric head on each way, differential pressure valve, metal cabinet, connections unit by radiofrequency (ref. E-25230). Note: Other distribution manifold equipments options see pages 72, 73, 74 and 75 of this catalogue. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 123 VALVES AND FITTINGS FOR RADIATORS energy efficiency THERMOSTATIC HEAD VALVES SAVINGS! UP TO 12% The Regulation concerning Heating Installations in Buildings (RITE) is mandatory and establishes the conditions that must be complied with by installations catering to the demand for thermal comfort and hygiene through heating, air conditioning and domestic hot water installations, to obtain rational energy use. Operative instruction ITE 02.11.2.2 of the RITE states that thermostatic valves must be fitted to all radiators installed in all rooms of a home, except rooms such as toilets, bathrooms, kitchens, halls and corridors. Harmony Aduna • Adaptable to Orkli thermostatic valves. • Adaptable to Orkli thermostatic valves. • Homologación en Normas Europeas (EN-215). • Homologación en Normas Europeas (EN-215). • Handle locking device. • Handle locking device. • White colour head. • White colour head. • Working range: • Working range: (5ºC-27ºC). (5ºC-27ºC). • Anti-freeze device. • Anti-freeze device. DESCRIPTION ARTICLE Wax sensor 2001 PIECES/BOX € 50 * Possibility of heads in metallic colours. Anti-theft DESCRIPTION ARTICLE HARMONY LX liquid sensor HARMONY LX wax sensor HARMONY SD remote sensor PIECES/BOX 60010 60110 60201 € 50 50 50 DESCRIPTION ARTICLE PIECES/BOX Anti-theft black Anti-theft white E-6616 E-14133 50 50 DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" E-18603 E-18604 15 10 € Differential pressure valve Arama White improvements DESCRIPTION ARTICLE Arama white PIECES/BOX 62035 € 50 € Note: Same discount as manifolds and distribution equipments section. THERMOSTATIC HEAD D SERIES GERMANY - M30X1,5 Harmony • Adaptable to thermostatic valves D series - M30x1,5. • Compatible with most of the valves from other European manufacturers (please check). • European standards (EN-215) approved. • Handle locking device. • White colour head. • Working range: (5ºC-27ºC). • Anti-freeze device. DESCRIPTION ARTICLE HARMONY LX liquid sensor - M30x1,5 HARMONY Wax sensor - M30x1,5 124 Tel.: +34 943 80 94 80 PIECES/BOX 60300 60302 Fax: +34 943 80 52 41 € 50 50 www.orkli.com Anti-theft D Series GERMANY M30x1,5 DESCRIPTION ARTICLE PIECES/BOX Anti-theft black M30x1,5 E-19790 50 € THERMOSTATIC VALVES BITUBE THERMOSTATIC VALVES: THERMOSTATIC VALVE PART Female connection to thread • Sleeve featuring mixed locking of O-ring and metal. • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). • Simple adjustment. • Manual handle easily changeable by a thermostatic head. • European norms (EN-215) approved. • For copper pipe add nut and olive. Interchangeable with straight one 67150 67450 DESCRIPTION ARTICLE Straight - 3/8” Straight - 1/2” PIECES/BOX € 50 50 PIECES/BOX 67250 67550 DESCRIPTION ARTICLE Reverse angle - 3/8” Reverse angle - 1/2” 67350 67650 PIECES/BOX € 50 50 Valves and ARTICLE Angle - 3/8” Angle - 1/2” ttings 04 fifor radiators DESCRIPTION € DESCRIPTION 50 50 ARTICLE Elbow - 1/2” 67540 PIECES/BOX € 50 Male connection for copper, PER, multilayer and polybuthilene pipe • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). • Simple adjustment. • Manual handle easily changeable by a thermostatic head. • Sleeve featuring mixed locking of O-ring and metal. Interchangeable with straight one DESCRIPTION ARTICLE PIECES/BOX € DESCRIPTION ARTICLE PIECES/BOX Angle - 3/8" Ø 10 (copper) 67180 50 Reverse angle - 3/8" Ø 10 (copper) 67380 50 Angle - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Angle - 1/2" Ø 10 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) 67190 67480 67490 50 50 50 Reverse angle - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Reverse angle - 1/2" Ø 10 (copper) Reverse angle - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) 67390 67680 67690 50 50 50 DESCRIPTION ARTICLE Straight - 3/8" Ø 10 (copper) Straight - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Straight - 1/2" Ø 10 (copper) Straight - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) PIECES/BOX 67280 67290 67580 67590 50 50 50 50 € DESCRIPTION ARTICLE Elbow - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) 67570 PIECES/BOX • Manual handle easily changeable by a thermostatic head. • Sleeve featuring mixed locking of O-ring and metal. • With special welding instructions. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION Angle - 3/8" Ø 12 Angle - 3/8" Ø 14 Angle - 1/2" Ø 14 Angle - 1/2" Ø 15 Angle - 1/2" Ø 16 Tel.: +34 943 80 94 80 ARTICLE 67100 67101 67400 67401 67402 Fax: +34 943 80 52 41 € 50 Connection for welding • Simple adjustment. € PIECES/BOX € 50 50 50 50 50 www.orkli.com 125 VALVES AND FITTINGS FOR RADIATORS THERMOSTATIC VALVES BITUBE THERMOSTATIC VALVES: THERMOSTATIC VALVE PART Female connection to thread • Simple adjustment. • Sleeve featuring mixed locking of O-ring and metal. • With protection handle. • For conical thread sleeve without sealing ring to radiator add "MC" to the • European norms (EN-215) approved. article. • For copper tube add nut and olive. • Accessories not included. (Pages. 147, 148, 149). Interchangeable with straight one DESCRIPTION ARTICLE Angle - 3/8” Angle - 1/2” 2040 2030 DESCRIPTION ARTICLE Straight - 3/8” Straight - 1/2” PIECES/BOX € 50 50 Reverse angle - 3/8” Reverse angle - 1/2” PIECES/BOX 2041 2031 DESCRIPTION ARTICLE 2042 2032 PIECES/BOX € 50 50 € DESCRIPTION 50 50 Elbow - 1/2” ARTICLE 63540 PIECES/BOX € 50 Male connection for copper, PER, multilayer and polybuthilene pipe • Simple adjustment. • For conical thread sleeve without sealing ring to radiator add "MC" to the • With protection handle. article. • Sleeve featuring mixed locking. • Accessories not included. (Pages. 147, 148, 149). Interchangeable with straight one DESCRIPTION ARTICLE PIECES/BOX Angle - 3/8" Ø 10 (copper) 63180 50 Angle - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Angle - 1/2" Ø 10 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) 63190 63480 2036 50 50 50 DESCRIPTION ARTICLE Straight - 3/8" Ø 10 (copper) Straight - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Straight - 1/2" Ø 10 (copper) Straight - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) 50 63290 63580 63590 50 50 50 DESCRIPTION Elbow - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Connection for welding DESCRIPTION • Simple adjustment. Angle - 3/8" Ø 12 Angle - 3/8" Ø 14 Angle - 1/2" Ø 14 Angle - 1/2" Ø 15 Angle - 1/2" Ø 16 • Sleeve featuring mixed locking. • With special welding instructions. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 ARTICLE 63380 63390 63680 63690 PIECES/BOX € 50 50 50 50 € • With protection handle. 126 DESCRIPTION Reverse angle - 3/8" Ø 10 (copper) Reverse angle - 3/8" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) Reverse angle - 1/2" Ø 10 (copper) Reverse angle - 1/2" Ø 12÷20 (PER,Mult,PB); 12÷16 (copper) PIECES/BOX 63280 € www.orkli.com ARTICLE 63570 ARTICLE 63100 63101 63400 63401 63402 PIECES/BOX € 50 PIECES/BOX 50 50 50 50 50 € THERMOSTATIC VALVES BITUBE THERMOSTATIC VALVES: D SERIES GERMANY Female connection to thread - Standard • Simple adjustment. • Sleeve featuring mixed locking of O-ring and metal. • Manual handle easily changeable by a thermostatic head. • Accessories not included. (Pages. 147, 148, 149). • European norms (EN-215) approved. 63140 MC 63440 MC 63040 MC PIECES/BOX € DESCRIPTION 50 50 50 ARTICLE Straight - 3/8" Straight - 1/2" Straight - 3/4" PIECES/BOX 63240 MC 63840 MC 63740 MC € Valves and ARTICLE Angle - 3/8" Angle - 1/2" Angle - 3/4" ttings 04 fifor radiators DESCRIPTION 50 50 50 Female connection to thread - Preliminary adjustment • Double adjustment. • Manual handle easily changeable by a thermostatic head. • Sleeve featuring mixed locking of O-ring and metal. • European norms (EN-215) approved. • Accessories not included. (Pages. 147, 148, 149). • Adjustment tool included. • Adjustment tool included. DESCRIPTION ARTICLE Angle - 3/8" Angle - 1/2" Angle - 3/4" 63110 MC 63410 MC 63010 MC PIECES/BOX € 50 50 50 DESCRIPTION ARTICLE Straight - 3/8" Straight - 1/2" Straight - 3/4" PIECES/BOX 63210 MC 63510 MC 63710 MC € 50 50 50 BITUBE THERMOSTATIC VALVES: MALE CONNECTION 1/2" EUROCONUS Thermostatic valve part Thermostatic valve part • Simple adjustment. • With protection handle. • Sleeve featuring mixed locking of O-ring and metal. • Simple adjustment. • Accessories not included. (Pages. 147, 148, 149). • Sleeve featuring mixed locking of O-ring and metal. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE Angle - 1/2" 67430 PIECES/BOX 50 € DESCRIPTION ARTICLE Angle - 1/2" 63430 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 PIECES/BOX € 50 www.orkli.com 127 VALVES AND FITTINGS FOR RADIATORS THERMOSTATIC VALVES MONOTUBE THERMOSTATIC VALVES: SPECIAL FOR REDUCED SPACES WALL-RADIATOR did you know...? this is a single-pipe thermostatic valve which is TOTALLY INTERCHANGEABLE with the manual single-pipe valve, as it has the SAME CENTRE DISTANCE? (30 mm.) Male connetion for copper, PER, multilayer and polybuthilene pipe Thermostatic male connection for copper, PER, multilayer and polybuthilene pipe • Total locking. • Total locking. • It maintains a constant charge-losing, whatever the in and output • It maintains a constant charge-losing, whatever the in and output senses maybe. senses maybe. • Featuring input sounder. • Featuring input sounder. • Thermostatic head not included. • Thermostatic head not included. • Manual handle easily changeable by a thermostatic head. • With protection handle. • Accessories not included. (Pages. 147, 148, 149). • Accessories not included. (Pages. 147, 148, 149). • Radiator 35% maximum derivation. • Radiator 35% maximum derivation. • Short distance from radiator-axis to connection nozzles (30 mm.) • Short distance from radiator-axis to connection nozzles (30 mm.) DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) PIECES/BOX 52390 € 20 DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52290 PIECES/BOX • Radiator 35% maximum derivation. • Radiator 35% maximum derivation. • Short distance from radiator-axis to connection nozzles (35 mm.) • Short distance from radiator-axis to connection nozzles (35 mm.) DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) PIECES/BOX 52910 52930 € 20 20 DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52810 52830 € 20 PIECES/BOX € 20 20 STANDARD • Radiator 32% maximum derivation. • Radiator 32% maximum derivation. • Short distance from radiator-axis to connection nozzles (47 mm.) • Short distance from radiator-axis to connection nozzles (47 mm.) DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 1/2" Ø 18 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 18 (copper) 128 Tel.: +34 943 80 94 80 PIECES/BOX 52710 53710 52730 53730 Fax: +34 943 80 52 41 € 20 20 20 20 DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 1/2" Ø 18 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 18 (copper) www.orkli.com ARTICLE 52610 53610 52630 53630 PIECES/BOX 20 20 20 20 € THERMOSTATIC VALVES MONOTUBE THERMOSTATIC VALVES: SPECIAL FOR SPECIAL BATHROOMS Male connetion for copper, PER, multilayer and polybuthilene pipe Thermostatic male connection for copper, PER, multilayer and polybuthilene pipe • Compact valve. Nickel plated finish. • Compact valve. Nickel plated finish. • Radiator 30% maximum derivation. • Radiator 30% maximum derivation. • Featuring input sounder. • Featuring input sounder. • Thermostatic head not included. • Thermostatic head not included. • Accessories not included. (Pages. 147, 148, 149). • Accessories not included. (Pages. 147, 148, 149). • With protection handle. Valves and ttings 04 fifor radiators • Manual handle easily changeable by a thermostatic head. FLOOR outlet model DESCRIPTION FLOOR outlet model ARTICLE Floor 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52510 PIECES/BOX € 20 Wall right 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Wall left 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE Floor 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52410 WALL outlet model DESCRIPTION DESCRIPTION PIECES/BOX € 20 WALL outlet model ARTICLE 52310 52110 PIECES/BOX 20 20 € DESCRIPTION ARTICLE Wall right 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Wall left 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Tel.: +34 943 80 94 80 52210 52010 Fax: +34 943 80 52 41 PIECES/BOX € 20 20 www.orkli.com 129 VALVES AND FITTINGS FOR RADIATORS THERMOSTATIC VALVES BITUBE THERMOSTATIC VALVES: SPECIAL FOR BITUBE INSTALLATIONS WITH MONOTUBE FORMAT did you know…? can the installation be made with two-pipe valves if the radiator has a single-pipe format? Advantages: • One single inlet point to the radiator. • The balancing is made from the valve itself. two-pipe valves with a single-pipe format are valves that have the singlepipe format on the outside, but which have no internal by-pass between flow and return, and therefore function as a valve and a lockshield but on the same valve? 130 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com THERMOSTATIC VALVES BITUBE THERMOSTATIC VALVES: SPECIAL FOR BITUBE INSTALLATIONS WITH MONOTUBE FORMAT FOR REDUCED SPACES Male connetion for copper, PER, multilayer and polybuthilene pipe Thermostatic male connection for copper, PER, multilayer and polybuthilene pipe • Radiator 100% derivation (only valid for bitube installations). • Compact valve. Nickel plated finish. • Featuring input sounder. • Radiator 100% derivation (only valid for bitube installations). • Accessories not included. (Pages. 147, 148, 149). • Featuring input sounder. • With protection handle. • Short distance from radiator-axis to connection nozzles (30 mm.) • Short distance from radiator-axis to connection nozzles (30 mm.) DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52490 PIECES/BOX € 20 DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52590 PIECES/BOX • With protection handle. • Short distance from radiator-axis to connection nozzles (35 mm.) • Short distance from radiator-axis to connection nozzles (35 mm.) 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52920 PIECES/BOX € 20 DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52820 € 20 • Thermostatic head not included. DESCRIPTION Valves and • Thermostatic head not included. ttings 04 fifor radiators • Accessories not included. (Pages. 147, 148, 149). PIECES/BOX € 20 STANDARD Male connetion for copper, PER, multilayer and polybuthilene pipe Thermostatic male connection for copper, PER, multilayer and polybuthilene pipe • Compact valve. Nickel plated finish. • Compact valve. Nickel plated finish. • Radiator 100% derivation (only valid for bitube installations). • Radiator 100% derivation (only valid for bitube installations). • Featuring input sounder. • Featuring input sounder. • Accessories not included. (Pages. 147, 148, 149). • Accessories not included. (Pages. 147, 148, 149). • Thermostatic head not included. • Thermostatic head not included. • Short distance from radiator-axis to connection nozzles (47 mm.) • Short distance from radiator-axis to connection nozzles (47 mm.) DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52720 PIECES/BOX 20 € DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Tel.: +34 943 80 94 80 52620 Fax: +34 943 80 52 41 PIECES/BOX € 20 www.orkli.com 131 VALVES AND FITTINGS FOR RADIATORS THERMOSTATIC VALVES CONNECTA PIPE CONNECTION SYSTEM Thermostatic adjustable valve DESCRIPTION ARTICLE 1/2" Angle - Pipe Ø exterior 15 mm copper, PER, multilayer 1/2" Angle - Pipe Ø exterior 16 mm copper, PER, multilayer Lockshield PIECES/BOX 67465 50 67466 50 € DESCRIPTION 1/2" Angle - Pipe Ø exterior 15 mm copper, PER, multilayer 1/2" Angle - Pipe Ø exterior 16 mm copper, PER, multilayer ARTICLE PIECES/BOX 88965 50 88966 50 Marking and removal tool DESCRIPTION ARTICLE PIECES/BOX Removal and marking tool for Ø 14, 15 and 16 pipes E-19838 - € € THERMOSTATIC UNIT Thermostat unit: thermostatic valve part + harmony head wax sensor + lockshield Male connection for copper, PER, multilayer and polybuthilene pipe • Valve part and lockshield connected identically to pipe. DESCRIPTION • Valve part and lockshield connected identically to radiator Angle - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) (mixed locking sleeve). • Single adjustment valve part. ARTICLE 68195 68196 PIECES/BOX € 8 8 Female connection to thread • Both nickel-plated. • Accessories not included. DESCRIPTION ARTICLE (Pages. 147, 148, 149). Angle - 3/8" Angle - 1/2" 68185 68186 8 8 ARTICLE PIECES/BOX energy efficiency PIECES/BOX € Connection for welding DESCRIPTION Angle - 3/8" Ø 12 Angle - 1/2" Ø 14 Angle - 1/2" Ø 15 68105 68405 68406 € 8 8 8 Thermostatic unit: thermostatic-adjustable valve part + lockshield Male connection for copper, PER, multilayer and polybuthilene pipe • Valve part and lockshield connected identically to pipe. DESCRIPTION • Valve part and lockshield connected identically to radiator Angle - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) (mixed locking sleeve). ARTICLE 68295 68495 PIECES/BOX € 8 8 • Single adjustment valve part. • Accessories not included. Female connection to thread (Pages. 147, 148, 149). DESCRIPTION ARTICLE Angle - 3/8" Angle - 1/2" 68285 68485 8 8 ARTICLE PIECES/BOX PIECES/BOX € Connection for welding DESCRIPTION Angle - 3/8" Ø 12 Angle - 1/2" Ø 14 Angle - 1/2" Ø 15 132 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 68205 68505 68506 8 8 8 € THERMOSTATIC UNIT energy efficiency U.K. SERIES Pack Harmony Pack Radiant • Fully reversible TRV. • Fully reversible TRV. • Handle locking device. • Handle locking device. • Complies with EN-215 series GB. • Complies with EN-215 series GB. • White colour head. • White colour head. • Working range: 5ºC-27ºC. • Working range: 5ºC-27ºC. • Anti-freeze device. • Anti-freeze device. • Extendable radiator connection • Extendable radiator connection sleeve. sleeve. • Pipe connection system by means of nut + olive. • Accessories included. DESCRIPTION DESCRIPTION ARTICLE Angle - 15 mm copper pipe Angle - 10/15 mm copper pipe Angle - 8/10/15 mm copper pipe Straight - 15 mm copper pipe Straight - 10/15 mm copper pipe Straight - 8/10/15 mm copper pipe 68002 68032 68022 68102 68132 68222 PIECES/BOX € 50 50 50 50 50 50 ARTICLE Angle - 15 mm copper pipe Angle - 10/15 mm copper pipe Angle - 8/10/15 mm copper pipe Straight - 15 mm copper pipe Straight - 10/15 mm copper pipe Straight - 8/10/15 mm copper pipe 62100 62110 62190 62200 62210 62290 PIECES/BOX € 50 50 50 50 50 50 Pack Plata Pack Ezie • Both nickel-plated. • Pack composed by: thermostatic valve body, Radiant thermostatic • Fully reversible TRV. Valves and means of nut + olive. • Accessories included. ttings 04 fifor radiators • Pipe connection system by head and lockshield. • Handle locking device. • Pipe connection system by means of nut + olive. • Advanced design small head. • Accessories included. • White colour head. • Working range: 5ºC-27ºC. • Anti-freeze device. • Extendable radiator connection sleeve. • Pipe connection system by means of nut + olive. • Accessories included. DESCRIPTION Angle - 15 mm copper pipe Angle - 8/10 mm copper pipe Straight - 15 mm copper pipe Straight - 8/10 mm copper pipe ARTICLE 68040 68041 68140 68141 PIECES/BOX 50 50 50 50 € DESCRIPTION ARTICLE Angle - 15 mm copper pipe Angle - 8/10 mm copper pipe Straight - 15 mm copper pipe Straight - 8/10 mm copper pipe Tel.: +34 943 80 94 80 68073 68074 68173 68174 Fax: +34 943 80 52 41 PIECES/BOX € 50 50 50 50 www.orkli.com 133 VALVES AND FITTINGS FOR RADIATORS SPECIAL VALVES FOR BATHROOMS: DELUXE SERIES Over the last few years, visual appearance has become very important in most areas. In bathroom design, radiator towel rails have led to the popularity of designer valves. Orkli has joined the market trend with its deluxe range of designer valves. 134 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com SPECIAL VALVES FOR BATHROOMS: DELUXE SERIES THERMOSTATIC VALVES Plata series energy efficiency • Adaptable to thermostatic valves. • Chrome plated finish. • Working range: 5ºC-27ºC. DESCRIPTION • Anti-freeze device. ARTICLE CX wax sensor 62024 € PIECES/BOX 50 BITUBE THERMOSTATIC VALVES ttings 04 fifor radiators Thermostatic valve part Valves and • Chrome plated and polished finish. • Simple adjustment. • European norms (EN-215) approved. • Manual handle easily changeable by a thermostatic head. • For copper tube add nut and olive. • Sleeve featuring mixed locking of O-ring and metal. • Accessories not included. (Page 136). Male connection for copper, PER, multilayer and polybuthilene pipe DESCRIPTION ARTICLE Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Straight - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 67890 67990 PIECES/BOX € 50 50 Female connection to thread DESCRIPTION ARTICLE Angle - 1/2" Straight - 1/2" 67850 67950 PIECES/BOX € 50 50 MONOTUBE THERMOSTATIC VALVES: SPECIAL BATHROOMS Male connetion for copper, PER, multilayer and polybuthilene pipe • Chrome plated and polished finish. • Radiator 30% maximum derivation. • Inlet probe included. • Thermostatic head not included. • Manual handle easily chageable by a thermostatic head. • Accessories not included. (Page 136). WALL outlet model DESCRIPTION FLOOR outlet model DESCRIPTION Floor - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE 52513 PIECES/BOX 20 € ARTICLE Wall right - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Wall left - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Tel.: +34 943 80 94 80 PIECES/BOX 52313 20 52113 20 Fax: +34 943 80 52 41 € www.orkli.com 135 VALVES AND FITTINGS FOR RADIATORS SPECIAL VALVES FOR BATHROOMS: DELUXE SERIES MONOTUBE THERMOSTATIC VALVES: SPECIAL BATHROOMS Bitube installations with monotube format • Chrome plated and polished finish. • Radiator 30% maximum derivation. • Inlet probe included. • Thermostatic head not included. • Manual handle easily chageable by a thermostatic head. • Accessories not included. (Page 136). WALL outlet model DESCRIPTION Wall right - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Wall left - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE PIECES/BOX 52713 20 52613 20 € COUPLING TO PIPE ACCESSORIES • Cap, O-ring, olive and nut. • Cap, O-ring, olive and nut. • Featuring two units for each group. • Featuring two units for each group. Male connection for copper pipe DESCRIPTION Male connection for PER and polybuthilene pipe ARTICLE PIECES/BOX E-5145 E-5147 E-5149 E-5151 40 40 40 40 DESCRIPTION ARTICLE PIECES/BOX M24X1,5 Ø16 x 12 M24X1,5 Ø18 x 14 M24X1,5 Ø20 x 16 E-17918 E-17919 E-17920 40 40 40 M24X1,5 Ø12 (red) M24X1,5 Ø14 (green) M24X1,5 Ø15 (brown) M24X1,5 Ø16 (yellow) € • Cap, O-ring, olive and nut. • Featuring two units for each group. Male connection for multilayer pipe 136 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com DESCRIPTION ARTICLE PIECES/BOX M24X1,5 Ø16 x 12,4 M24X1,5 Ø16 x 12 M24X1,5 Ø20 x 16 E-17921 E-17922 E-17923 40 40 40 € SPECIAL VALVES FOR BATHROOMS: DELUXE SERIES WHITE SERIES Manual valves DESCRIPTION ARTICLE Angle- 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 82216 Straight - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 82316 PIECES/BOX € 50 50 DESCRIPTION ARTICLE Angle - 1/2" Straight - 1/2" 82016 82116 PIECES/BOX € 50 50 Lockshields Lockshields Male connection for copper, PER, multilayer and polybuthilene pipe DESCRIPTION Female connection to thread Valves and Male connection for copper, PER, multilayer and polybuthilene pipe ttings 04 fifor radiators Manual valves ARTICLE Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 88216 Straight - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 88316 PIECES/BOX 50 50 € Female connection to thread DESCRIPTION ARTICLE Angle - 1/2" Straight - 1/2" 88016 88116 DESCRIPTION ARTICLE PIECES/BOX € 50 50 Unit: Valve part + lockshield Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Tel.: +34 943 80 94 80 83216 Fax: +34 943 80 52 41 PIECES/BOX € 8 www.orkli.com 137 VALVES AND FITTINGS FOR RADIATORS SPECIAL VALVES FOR BATHROOMS: DELUXE SERIES CHROME PLATED SERIES Manual valves Manual valves Male connection for copper, PER, multilayer and polybuthilene pipe DESCRIPTION ARTICLE PIECES/BOX Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 82215 Straight - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 82315 € 50 50 Female connection to thread DESCRIPTION ARTICLE Angle - 1/2" Straight - 1/2" 82015 82115 PIECES/BOX € 50 50 Lockshields Lockshields Male connection for copper, PER, multilayer and polybuthilene pipe DESCRIPTION ARTICLE PIECES/BOX Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 88215 Straight - 1/2"Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 88315 € 50 50 Female connection to thread DESCRIPTION ARTICLE Angle - 1/2" Straight - 1/2" 88015 88115 DESCRIPTION ARTICLE PIECES/BOX € 50 50 Unit: Valve part + lockshield Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 138 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 83215 PIECES/BOX 8 € MANUAL BITUBE VALVES FEMALE CONNECTION TO THREAD COPLINE: Simple adjustment • Sleeve featuring mixed locking of O-ring and metal. • Protection cowl. • For copper tube add nut and olive. • Lockshields. (Page. 142, 143) • For conical thread sleeve without sealing ring to radiator add "MC" to the article. ARTICLE Angle - 3/8” Angle - 1/2” Angle - 3/4” 1115 1125 1135 PIECES/BOX € 60 60 60 DESCRIPTION ARTICLE Straight - 3/8” Straight - 1/2” Straight - 3/4” DESCRIPTION Elbow - 1/2” 1116 1126 1136 ARTICLE 82140 PIECES/BOX Valves and DESCRIPTION ttings 04 fifor radiators • Accessories not included. (Pages. 147, 148, 149). € 60 60 60 PIECES/BOX € 60 WOODLINE: Double adjustment • Sleeve featuring mixed locking of O-ring and metal. • Protection cowl. • For copper tube add nut and olive. • Lockshields. (Page. 142, 143) • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE Angle - 3/8” Angle - 1/2” Angle - 3/4” 1615 1625 1535 PIECES/BOX 60 60 60 € DESCRIPTION ARTICLE Straight - 3/8” Straight - 1/2” Straight - 3/4” DESCRIPTION Elbow - 1/2” Tel.: +34 943 80 94 80 1616 1626 1536 ARTICLE 85160 Fax: +34 943 80 52 41 PIECES/BOX € 60 60 60 PIECES/BOX € 60 www.orkli.com 139 VALVES AND FITTINGS FOR RADIATORS MANUAL BITUBE VALVES MALE CONNECTION FOR COPPER, PER, MULTILAYER AND POLYBUTHILENE PIPE UREPEL: Simple adjustment • Sleeve featuring mixed locking of O-ring and metal. • Protection cowl. • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE Angle - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) PIECES/BOX 81210 82210 € 60 60 DESCRIPTION ARTICLE Straight - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 81310 Straight - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 82310 DESCRIPTION Elbow - 1/2” ARTICLE PIECES/BOX € 60 60 PIECES/BOX 82340 60 ARTICLE PIECES/BOX € UREPEL: Double adjustment • Sleeve featuring mixed locking of O-ring and metal. • Protection cowl. • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE PIECES/BOX € DESCRIPTION Angle - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 84260 60 Straight - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 84360 60 Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 1210 60 Straight - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 85360 60 DESCRIPTION ARTICLE Elbow - 1/2" Ø12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 85340 140 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com PIECES/BOX 60 € € MANUAL BITUBE VALVES CONNECTION FOR WELDING WELDLINE: With assembled handle • For conical thread sleeve without sealing ring to radiator add "MC" to the article. Angle - 3/8” Ø 12 Angle - 3/8” Ø 14 Angle - 1/2” Ø 14 Angle - 1/2” Ø 15 Angle - 1/2” Ø 16 ARTICLE PIECES/BOX 1315 1310 1320 1325 1330 € 60 60 60 60 60 Angle - 1/2" female connection to thread ARTICLE 1316 1311 1321 1326 1331 PIECES/BOX € 60 60 60 60 60 Unit: Manual valve part + lockshield PIECES/BOX 82200 ARTICLE Straight - 3/8” Ø 12 Straight - 3/8” Ø 14 Straight - 1/2” Ø 14 Straight - 1/2” Ø 15 Straight - 1/2” Ø 16 Unit: Manual valve part + lockshield DESCRIPTION DESCRIPTION Valves and DESCRIPTION ttings 04 fifor radiators • Simple adjustment. • Sleeve featuring mixed locking of O-ring and metal. • Protection cowl. € 25 DESCRIPTION ARTICLE Angle - 1/2" male connection for copper 82201 PIECES/BOX € 25 MALE CONNECTION EUROCONUS • Simple adjustment. • Sleeve featuring mixed locking of O-ring and metal. DESCRIPTION ARTICLE Angle - 3/8" Angle - 1/2" 81000 82000 • With protection handle. • Nickel-plated. PIECES/BOX € DESCRIPTION Straight - 3/8" Straight - 1/2" 60 60 ARTICLE 81100 82100 PIECES/BOX € 60 60 FRANCE SERIES WOODLINE: Without assembled handle • Simple adjustment. • Sleeve featuring mixed locking of O-ring and metal. DESCRIPTION ARTICLE • Nickel-plated. • Body and handle assembly are supplied separately. PIECES/BOX Angle - 3/8” Ø 12 Angle - 3/8” Ø 14 Angle - 1/2” Ø 14 Angle - 1/2” Ø 15 1317 1312 1322 1327 60 60 60 60 Angle - 1/2” Ø 16 1332 60 € DESCRIPTION ARTICLE Straight - 3/8” Ø 12 Straight - 3/8” Ø 14 Straight - 1/2” Ø 14 Straight - 1/2” Ø 15 Straight - 1/2” Ø 16 1318 1313 1323 1328 1333 PIECES/BOX DESCRIPTION ARTICLE PIECES/BOX Handle assembly E-6447 60 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € 60 60 60 60 60 www.orkli.com € 141 VALVES AND FITTINGS FOR RADIATORS MANUAL MONOTUBE VALVES MALE CONNECTION FOR COPPER, PER, MULTILAYER AND POLYBUTHILENE PIPE UNILINE: Simple adjustment UNILINE: Double adjustment • Total locking. • Total locking. • Radiator 100% derivation. • Radiator 100% derivation. • It maintains a constant charge-losing, whatever the in and output • It maintains a constant charge-losing, whatever the in and output senses maybe. senses maybe. • Featuring input sounder. • Featuring input sounder. • Accessories not included. (Pages. 147, 148, 149). • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 1/2" Ø 18 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 18 (copper) PIECES/BOX 1816 1817 1826 1827 € 20 20 20 20 DESCRIPTION 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 1/2" Ø 18 (copper) 3/4" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 3/4" Ø 18 (copper) ARTICLE 1865 1866 1875 1876 PIECES/BOX € 20 20 20 20 LOCKSHIELDS MANUALLY OPERATED AND THERMOSTATIC VALVES WOODLINE-COPLINE: Female connection to thread • Sleeve featuring mixed locking of O-ring and metal. • For copper tube add nut and olive. • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). 142 DESCRIPTION ARTICLE Angle - 3/8" Angle - 1/2" Angle - 3/4" 1015 1025 1035 Tel.: +34 943 80 94 80 PIECES/BOX Fax: +34 943 80 52 41 € 60 60 60 DESCRIPTION Straight - 3/8" Straight - 1/2" Straight - 3/4" www.orkli.com ARTICLE 1016 1026 1036 DESCRIPTION ARTICLE Elbow - 1/2" 88140 PIECES/BOX € 60 60 60 PIECES/BOX 60 € LOCKSHIELDS MANUALLY OPERATED AND THERMOSTATIC VALVES UREPEL: Male connection for copper, PER, multilayer and polybuthilene pipe • Sleeve featuring mixed locking of O-ring and metal. • For conical thread sleeve without sealing ring to radiator add "MC" to the article. • Accessories not included. (Pages. 147, 148, 149). PIECES/BOX € DESCRIPTION ARTICLE PIECES/BOX 87210 1220 60 60 Straight - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 87310 Straight - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 88310 60 60 Angle - 3/8" Ø 10 (copper) Angle - 1/2" Ø 10 (copper) 87230 88230 60 60 Straight - 3/8" Ø 10 (copper) Straight - 1/2" Ø 10 (copper) 60 60 DESCRIPTION Elbow - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ARTICLE PIECES/BOX 88340 € 60 87330 88330 DESCRIPTION ARTICLE PIECES/BOX Elbow sleeve E-11729 60 ARTICLE PIECES/BOX € Valves and ARTICLE Angle - 3/8" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) Angle - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) ttings 04 fifor radiators DESCRIPTION € WELDLINE: Connection for welding: assembled • For conical thread sleeve without sealing ring to radiator add "MC" to the article. DESCRIPTION Angle - 3/8” Ø 12 Angle - 3/8” Ø 14 Angle - 1/2” Ø 14 Angle - 1/2” Ø 15 Angle - 1/2” Ø 16 ARTICLE PIECES/BOX 1415 1410 1420 1425 1430 € 60 60 60 60 60 DESCRIPTION Straight - 3/8” Ø 12 Straight - 3/8” Ø 14 Straight - 1/2” Ø 14 Straight - 1/2” Ø 15 Straight - 1/2” Ø 16 1416 1411 1421 1426 1431 € 60 60 60 60 60 MALE CONNECTION EUROCONUS For manually and thermostatic valves • Sleeve featuring mixed locking of O-ring and metal. • Nickel-plated. • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE Angle - 3/8" Angle - 1/2" 87000 88000 PIECES/BOX 60 60 € DESCRIPTION Straight - 3/8" Straight - 1/2" Tel.: +34 943 80 94 80 ARTICLE 87100 88100 Fax: +34 943 80 52 41 PIECES/BOX € 60 60 www.orkli.com 143 VALVES AND FITTINGS FOR RADIATORS LOCKSHIELDS Follow the direction of the arrows when installing. LOCKSHIELD VALVE SET Floor straight thermostatic monotube and bitube Wall straight thermostatic monotube and bitube • Supplied with manual adjustment handle, nut of Ø 15 mm. for pipe fitting. • Supplied with manual adjustment handle, nut of Ø 15 mm. for pipe fitting. • Between centres of bottom fitting 35 mm. • Between centres of bottom fitting 35 mm. • Accessories not included. (Pages. 147, 148, 149). • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION Monotube Bitube DESCRIPTION Monotube Bitube DESCRIPTION Monotube Bitube ARTICLE PIECES/BOX 54570 54560 ARTICLE 10 10 € 10 10 DESCRIPTION Monotube Bitube PIECES/BOX 54500 54510 DESCRIPTION Monotube Bitube PIECES/BOX 54590 54580 ARTICLE € € 10 10 DESCRIPTION Monotube Bitube ARTICLE 54470 54460 ARTICLE 54490 54480 ARTICLE 54400 54410 PIECES/BOX € 10 10 PIECES/BOX € 10 10 PIECES/BOX € 10 10 FOR MONOTUBE-BITUBE INSTALLATIONS Male connection for copper, PER, multilayer and polybuthilene pipe: monotube • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE PIECES/BOX Floor - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52550 Floor - 1/2" Ø 18 (copper) 53550 € 40 40 DESCRIPTION ARTICLE Wall - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52450 Wall - 1/2" Ø 18 (copper) 53450 PIECES/BOX € 40 40 Male connection for copper, PER, multilayer and polybuthilene pipe: bitube • Accessories not included. (Pages. 147, 148, 149). DESCRIPTION ARTICLE PIECES/BOX Floor - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52560 Floor - 1/2" Ø 18 (copper) 53560 144 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € 40 40 DESCRIPTION ARTICLE Wall - 1/2" Ø 12÷20 (PER,Mult.PB); Ø 12÷16 (copper) 52460 Wall - 1/2" Ø 18 (copper) 53460 www.orkli.com PIECES/BOX 40 40 € LOCKSHIELDS Plata series • Both lockshield cap and valve handwheel. • Both lockshield cap and valve handwheel. • EPDM O-ring sealing system for spindle. • EPDM O-ring sealing system for spindle. • Extendable1/2" BSP connecting tail. • Extendable1/2" BSP connecting tail. • Pipe connection system by means of nut + olive. • Pipe connection system by means of nut + olive. • Fittings included. • Fittings included. DESCRIPTION Angle - 15 mm copper pipe Angle - 8/10 mm copper pipe Straight - 15 mm copper pipe Straight - 8/10 mm copper pipe ARTICLE 80000 80100 80011 80111 PIECES/BOX € 50 50 50 50 DESCRIPTION ARTICLE Angle - 15 mm copper pipe Angle - 8/10 mm copper pipe Straight - 15 mm copper pipe Straight - 8/10 mm copper pipe 80012 80013 80112 80113 PIECES/BOX Valves and White series ttings 04 fifor radiators U.K. SERIES € 50 50 50 50 PURGING DEVICES Manual Automatic • Metallic. • Natural india-rubber filter. DESCRIPTION 1/8" ARTICLE 19000322 PIECES/BOX € 25 DESCRIPTION ARTICLE 3/8" 1/8" D-7584 D-7074 Angle purging device with floater PIECES/BOX € 100 100 Purging device with automatic floater DESCRIPTION ARTICLE 1" right 1" left D-7075 D-7076 PIECES/BOX € 100 100 DESCRIPTION ARTICLE 3/8" 1/2" D-7073 D-7586 PIECES/BOX € 100 100 Automatic closing valve DESCRIPTION ARTICLE 3/8" 1/2" D-7071 D-7585 PIECES/BOX 100 100 € DESCRIPTION ARTICLE 3/8" 1/2" E-25258 E-25259 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 PIECES/BOX € 100 100 www.orkli.com 145 VALVES AND FITTINGS FOR RADIATORS HYDRAULIC MODULES FOR RADIATORS WITH INTEGRATED TAPS did you know...? hydraulic modules are normally used for radiators with integrated valves? This type of valves is therefore only used for connecting the pipes to the radiator. FOR BITUBE INSTALLATIONS • Adjustment and isolation by means of globe valves. • Connection to radiator by means of 3/4" female nut (convertible to 1/2" male). • For copper, PER, multilayer and polybuthilene pipe. • Accessories not included. (Pages. 147, 148, 149). FLOOR outlet model WALL outlet model DESCRIPTION ARTICLE H3/4" - M24 (Orkli standard joint) H3/4" - G3/4" Euroconus PIECES/BOX 80020 80021 € 50 50 DESCRIPTION H3/4" - M24 (Orkli standard joint) H3/4" - G3/4" Euroconus ARTICLE 80023 80024 PIECES/BOX € 50 50 FOR MONOTUBE INSTALLATIONS • Adjustment and isolation by means of globe valves. • Connection to radiator by means of 3/4" female nut (convertible to 1/2" male). • For copper, PER, multilayer and polybuthilene pipe. • Accessories not included. (Pages. 147, 148, 149). FLOOR outlet model WALL outlet model DESCRIPTION ARTICLE H3/4" - M24 (Orkli standard joint) H3/4" - G3/4" Euroconus PIECES/BOX 80026 80027 € 50 50 DESCRIPTION H3/4" - M24 (Orkli standard joint) H3/4" - G3/4" Euroconus ARTICLE 80029 80032 PIECES/BOX € 50 50 ADAPTERS FOR HYDRAULIC MODULES • 2 units per bag. • 2 units per bag. DESCRIPTION ARTICLE Male G3/4" - G1/2" - for radiators with female connection G1/2" 146 Tel.: +34 943 80 94 80 PIECES/BOX 80035 Fax: +34 943 80 52 41 € - DESCRIPTION Cone adaptor for radiators with male cone connection G3/4" www.orkli.com ARTICLE 80036 PIECES/BOX - € ACCESSORIES COUPLING TO PIPE ACCESSORIES Male connection for multilayer pipe Don’t take chances with accessories! • Cap with seals, O-ring, ring and nut. • Featuring two units for each group. new • Greater closing surface with a double seal • Reduces the chance of leaks by 80% • New design Female connection to thread DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø16x2 V-01030 30 € • Nut. ARTICLE PIECES/BOX F-4425 F-4371 F-4416 F-4370 F-4369 - € Female connection to thread • Nut and olive. DESCRIPTION Male connection for copper pipe • Cap, O-ring, olive and nut. • Featuring two units for each group. DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø10 (white) M24x1,5 Ø12 (red) M24x1,5 Ø14 (green) M24x1,5 Ø15 (brown) M24x1,5 Ø16 (yellow) M26x1,5 Ø18 (white) E-8473 E-5135 E-5137 E-5139 E-5141 E-5427 40 40 40 40 40 40 € Brass - 3/8" - Ø12 Brass - 1/2" - Ø12 Brass - 1/2" - Ø14 Brass - 1/2" - Ø15 Brass - 1/2" - Ø16 Teflon - 3/8" - Ø12 Teflon - 1/2" - Ø12 Teflon - 1/2" - Ø14 Teflon - 1/2" - Ø15 Teflon - 1/2" - Ø16 ARTICLE PIECES/BOX F-3958 F-3960 F-4413 F-3962 F-4144 F-5251 F-5037 F-5038 F-5192 F-5039 - € Valves and Nickel-plated - 3/8" - Ø12 Nickel-plated - 1/2" - Ø12 Nickel-plated - 1/2" - Ø14 Nickel-plated - 1/2" - Ø15 Nickel-plated - 1/2" - Ø16 ttings 04 fifor radiators DESCRIPTION Male connection for multilayer pipe • Cap with seals, O-ring, ring and nut. Male connection for PER pipe • Featuring two units for each group. • Cap, O-ring, olive and nut. • Featuring two units for each group. DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø12x1 M24x1,5 Ø12x2 M24x1,5 Ø14x2 M24x1,5 Ø16x1,5 M24x1,5 Ø16x1,8 M24x1,5 Ø16x1,9 M24x1,5 Ø16x2 M24x1,5 Ø16x2,2 M24x1,5 Ø17x2 M24x1,5 Ø18x2 M24x1,5 Ø18x2,5 M24x1,5 Ø20x1,9 M24x1,5 Ø20x2 M24x1,5 Ø20x3 M24x1,5 Ø20x3,4 E-13676 E-13673 E-13758 E-13679 E-15700 E-18871 E-13768 E-18872 E-13682 E-13780 E-13735 E-18873 E-13787 E-13741 E-13738 40 40 40 40 40 40 40 40 40 40 40 40 40 40 40 € DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø14x2 M24x1,5 Ø16x2 M24x1,5 Ø16x2,25 M24x1,5 Ø18x2 M24x1,5 Ø20x2 M24x1,5 Ø20x2,25 M24x1,5 Ø20x2,5 M24x1,5 Ø17,5x13 (Gladiator) E-13646 E-13727 E-13637 E-13667 E-13670 E-13643 E-13640 E-13793 40 40 40 40 40 40 40 40 € Male connection for Polybuthilene pipe • Cap with seals, O-ring, ring and nut. • Featuring two units for each group. Adapter connector for manifold outlet DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø15x1,7 M24x1,5 Ø16x1,8 M24x1,5 Ø20x2,3 E-13816 E-15700 E-19570 40 40 40 € Male connection for copper pipe • "Fast" nut for copper pipe. DESCRIPTION ARTICLE ½” M-Orkli accessory joint M24x1,5 ½” F-Orkli accessory joint M24x1,5 ¾”M-Orkli accessory joint M24x1,5 ¾”F-Orkli accessory joint M24x1,5 M24 • 1,5 - M24 • 1,5 M24 • 1,5 Male - M24 • 1,5 Female E-13062 E-25169 E-23860 E-25170 E-23859 V-00564 PIECES/BOX 300 300 300 300 300 300 € • Featuring two units for each group. DESCRIPTION ARTICLE PIECES/BOX M24x1,5 Ø12 M24x1,5 Ø14 M24x1,5 Ø15 M24x1,5 Ø16 E-14000 E-14001 E-14002 E-14003 80 80 80 80 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com 147 VALVES AND FITTINGS FOR RADIATORS ACCESSORIES COUPLING TO PIPE ACCESSORIES Elbow Telescopic union tail piece 1/2" • Extension range 20 mm (standard Orkli sleeve length - 2 mm. + 18 mm.). • 1/2" coupling to radiator. • Sealing-to-radiator area by means of EPDM sealing ring. DESCRIPTION ARTICLE PIECES/BOX Telescopic union tail piece 1/2" - 20 mm E-19733 Telescopic union tail piece 3/8" - 20 mm outlet at 1⁄2” valve E-20185 DESCRIPTION ARTICLE PIECES/BOX Elbow for wall monotube E-9082 40 € € - Nickel-plated extension pipe Bridge for installations testing DESCRIPTION ARTICLE PIECES/BOX Copper guide bridge at 35 mm for installations testing for monotube valves Accessory for bitube installations E-19863 - E-22769 - € DESCRIPTION ARTICLE PIECES/BOX 118 mm. 1/2" valve connection wall outlet pipe - Ø14 118 mm. 1/2" valve connection wall outlet pipe - Ø15 118 mm. M24 x 1,5 valve connection wall outlet pipe - Ø 15 (Home refurbishment) E-19819 - E-20195 - E-23794 - € USEFUL TOOLS Pipe cutter for copper pipes Pipe-cutting scissors for PEX-PP-PE and PB pipes of up to 26 mm diameter DESCRIPTION ARTICLE PIECES/BOX Pipe cutter for copper pipes to Ø 35 mm. E-19860 - € DESCRIPTION ARTICLE PIECES/BOX Pipe cutting scissors SRCUT 1 DESCRIPTION ARTICLE PIECES/BOX 100 cm. Ø 15 mm. E-10857 - ARTICLE PIECES/BOX Interior and exterior reamer/ deburrer for copper, plastic and multilayer pipes € Copper tube DESCRIPTION ARTICLE PIECES/BOX Interior and exterior reamer/deburrer for copper, plastic and multilayer pipes to Ø 40 m. E-19861 - € Hex Allen key € Decorative pieces • For monotube thermostatic regulation. • For regulating valves and lockshields. • For fixing sleeve to radiator of 3/8", 1/2" and monotube. 148 DESCRIPTION ARTICLE PIECES/BOX Thermostatic shaft Valve and lock shield shaft Bitube sleeve 3/8" - 10 mm. Bitube sleeve 1/2" - 12 mm. Monotube sleeve 1/2" - 19 mm. E-17514 E-17515 E-17516 E-17517 E-17518 10 10 10 10 10 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € DESCRIPTION Double Simple www.orkli.com 19000313 19000304 50 100 € ACCESSORIES ACCESSORIES FOR COUPLING TO RADIATOR - FRANCE SERIES KIT FOR REAR FIXING TO RADIATOR The pipes are fitted during the building work, embedded in the wall. The intakes are provided approximately halfway to where the radiator is going to be fitted. 2 3 The accessories that will help to connect the pipes are fitted. 4 First of all connect to the bridge that is going to allow the installation’s pressure test to be carried out. This will protect the pipes from dirt and knocks until the radiators are fitted. Once all the other trades have down their work, fit the accessories that are going to facilitate the connection of the radiators. 5 Finally fit the radiator with the pipe connections behind it. Valves and ttings 04 fifor radiators 1 DESCRIPTION 1/2" M24x1,5 1/2" (unit D-10865+2036+1220) M24x1,5 (unit D-10867+2036+1220) ARTICLE PIECES/BOX D-10865 D-10867 65492 65493 1 1 1 1 € ACCESSORIES FOR COUPLING TO RADIATOR - U.K. SERIES Drain off tail Accessories for copper pipe • Valid for TRV's as well as for lockshield valves. • Valid for TRV's as well as for • EPDM O-ring sealing system for spindle. lockshield valves. • Chromed finish. DESCRIPTION DESCRIPTION 15 mm. drain off tail ARTICLE 80200 PIECES/BOX € - Accessories for plastic pipe • Valid for TRV's as well as for lockshield valves. ARTICLE Accessories for 15 mm - 5 mm olive E-14504 Accessories for 8 & 10 mm pipe F-9892 pair of adaptors Complete set for 15 mm - extensible tail 80016 + 2 nuts + 215 mm olive Complete set for 8 & 10 mm - extensible tail + 80018 2 nuts + pair of adaptors PIECES/BOX € - Push fit elbow (John Guest) • Valid for valves and lockshields. DESCRIPTION ARTICLE PIECES/BOX Accessories for 15 mm. plastic pipe (thickness 1,7 mm to 2,0 mm.) Accessories for 20 mm. plastic pipe (thickness 1,5 mm. to 1,8 mm.) E-18511 - E-18804 - € • Chromed finish. • Valid for 10 mm pipe. DESCRIPTION ARTICLE PIECES/BOX 15 mm. push fit elbow E-22332 - Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 149 VALVES AND FITTINGS FOR RADIATORS HYDRAULIC CHARACTERISTICS Bitube thermostatic valves 1/2" d.p. (mmca) 10000 Reverse angle 100% open 1407,0 l/h Closed 1 turn 919,8 l/h Closed 2 turns 50,4 l/h 1000 100 10 10 100 1000 Angle 100% open Closed 1 turn Closed 2 turns 1414,4 l/h 793,0 l/h 223,5 l/h Straight 100% open Closed 1 turn Closed 2 turns 1036,3 l/h 691,6 l/h 263,6 l/h Flow (l/h) Bitube thermostatic valves 3/8" Reverse angle 100% open 1279,9 l/h Closed 1 turn 851,1 l/h Closed 2 turns 58,8 l/h d.p. (mmca) 10000 1000 100 10 10 100 Flow (l/h) 150 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 1000 Angle 100% open Closed 1 turn Closed 2 turns 1204,5 l/h 784,2 l/h 43,6 l/h Straight 100% open Closed 1 turn Closed 2 turns 1044,3 l/h 844,7 l/h 67,8 l/h HYDRAULIC CHARACTERISTICS Thermostatic monotube valve special for reduced spaces Reduced spaces (type 52390) Thermostat and lockshield opens 100% 1788,9 l/h Thermostat and lockshield closed 1841,0 l/h Thermostat open 100% and lockshield open 25% 1906,4 l/h Thermostat open 100% and lockshield open 50% 2044,4 l/h Thermostat open 100% and lockshield open 75% 2026,1 l/h Reduced spaces (type 52910) Thermostat and lockshield opens 100% 1947,6 l/h Thermostat and lockshield closed 1143,2 l/h Thermostat open 100% and lockshield open 25% 1402,6 l/h Thermostat open 100% and lockshield open 50% 1569,5 l/h Thermostat open 100% and lockshield open 75% 1763,5 l/h 100 10 1000 Flow (l/h) Thermostatic monotube valve standard Thermostat and lockshield opens 100% Thermostat and lockshield closed Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% d.p. (mmca) 10000 1000 1921,9 l/h 1269,6 l/h 1500,9 l/h 1706,7 l/h 1902,6 l/h 100 10 1000 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 151 Valves and 1000 ttings 04 fifor radiators d.p. (mmca) 10000 VALVES AND FITTINGS FOR RADIATORS HYDRAULIC CHARACTERISTICS Bathroom thermostatic monotube valve d.p. (mmca) 10000 1000 Floor Thermostat and lockshield opens 100% Thermostat and lockshield closed Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% 2116,1 l/h 1389,4 l/h 1912,4 l/h 2044,2 l/h 2105,5 l/h Wall Thermostat and lockshield opens 100% Thermostat and lockshield closed Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% 1959,3 l/h 1213,4 l/h 1636,0 l/h 1880,3 l/h 1950,6 l/h 100 10 1000 Flow (l/h) Bathroom thermostatic monotube valve d.p. (mmca) 10000 1000 100 10 1000 Flow (l/h) 152 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com HYDRAULIC CHARACTERISTICS 1000 100 10 10 Reduced spaces (type 52490) Thermostat and lockshield opens 100% Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% 874,9 l/h 463,3 l/h 687,5 l/h 854,4 l/h Reduced spaces (type 52920) Thermostat and lockshield opens 100% Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% 726,2 l/h 277,0 l/h 352,1 l/h 570,7 l/h Thermostat and lockshield opens 100% Thermostat open 100% and lockshield open 25% Thermostat open 100% and lockshield open 50% Thermostat open 100% and lockshield open 75% 698,0 l/h 372,7 l/h 481,6 l/h 615,8 l/h 100 Flow (l/h) Bitube installations valves with monotube format d.p. (mmca) 10000 1000 100 10 10 100 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 153 Valves and d.p. (mmca) 10000 ttings 04 fifor radiators Thermostatic monotube valve special for reduced spaces VALVES AND FITTINGS FOR RADIATORS HYDRAULIC CHARACTERISTICS Bitube valves series Copline, Woodline Angle 3/4" d.p. (mmca) 10000 Angle 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns Closed 6 turns Closed 7 turns 1000 100 10 10 3340,1 l/h 3133,6 l/h 2719,2 l/h 2160,5 l/h 1604,4 l/h 1111,3 l/h 745,8 l/h 325,8 l/h 1000 Flow (l/h) Bitube valves series Copline, Woodline Straight 3/4" d.p. (mmca) 10000 Straight 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns Closed 6 turns 1000 100 10 10 100 1000 Flow (l/h) 154 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 2457,4 l/h 2299,4 l/h 1932,1 l/h 1404,0 l/h 1004,0 l/h 634,1 l/h 276,2 l/h HYDRAULIC CHARACTERISTICS Bitube valves series Copline, Woodline, Urepel, Weldline, Epelur Angle 1/2" Angle 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns 1000 1990,3 l/h 1778,3 l/h 1454,2 l/h 1049,6 l/h 685,6 l/h 295,2 l/h ttings 04 fifor radiators d.p. (mmca) 10000 10 Valves and 100 10 1000 Flow (l/h) Bitube valves series Copline, Woodline, Urepel, Weldline, Epelur Straight 1/2" d.p. (mmca) 10000 Straight 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns 1000 1529,4 l/h 1510,7 l/h 1491,2 l/h 1413,1 l/h 1263,6 l/h 1012,1 l/h 100 10 100 1000 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 155 VALVES AND FITTINGS FOR RADIATORS HYDRAULIC CHARACTERISTICS Bitube valves series Copline, Woodline, Urepel, Weldline, Epelur Angle 3/8" d.p. (mmca) 10000 Angle 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns 1000 1794,9 l/h 1612,4 l/h 1394,2 l/h 1092,7 l/h 755,8 l/h 364,6 l/h 100 10 10 100 1000 Flow (l/h) Bitube valves series Copline, Woodline, Urepel, Weldline, Epelur Straight 3/8" d.p. (mmca) 10000 Straight 100% open Closed 1 turn Closed 2 turns Closed 3 turns Closed 4 turns Closed 5 turns 1000 100 10 1000 100 Flow (l/h) 156 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 1376,6 l/h 1371,2 l/h 1353,2 l/h 1343,2 l/h 1245,1 l/h 1064,3 l/h HYDRAULIC CHARACTERISTICS Monotube valves 1/2" 100% open Closed 1 turn Closed 2 turns Closed 3 turns 1000 2724,7 l/h 2521,0 l/h 2294,5 l/h 2007,4 l/h 3/4" 100 10 2263,1 l/h 2227,3 l/h 2201,5 l/h 1965,7 l/h Valves and 100% open Closed 1 turn Closed 2 turns Closed 3 turns ttings 04 fifor radiators d.p. (mmca) 10000 1000 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 157 05 energy efficiency Zone valves Non detachable zone valves • Standard zone valves • Normally Open Standard zone valves • M-M Solar zone valves Detachable zone valves • Standard zone valves Normally Closed in A • Standard zone valves Normally Open in A • United Kingdom and Ireland zone valves • USA - Canada zone valves Zone • Solar zone valves 05 valves • M-M Standard zone valves ZONE VALVES NON DETACHABLE ZONE VALVES • Motor valve "All-Nil". • Spring return. • Hysteresis motor 230V 50Hz. • Cable length 60 cm. • Option with 24V 50Hz motor by special order. • F-F / M-M option upon request. improvements STANDARD ZONE VALVES • More robust transmission • Normally closed in A. 2 ways - Without run-end micro: 3 wires DESCRIPTION 2 ways - With run-end micro: 5 wires ARTICLE 1/2" 3/4" 1" PIECES/BOX 30110200 30210200 30310200 € 10 10 10 DESCRIPTION 3 ways - Without run-end micro: 3 wires DESCRIPTION 30120200 30220200 30320200 PIECES/BOX € 10 10 10 3 ways - With run-end micro: 5 wires ARTICLE 1/2" 3/4" 1" ARTICLE 1/2" 3/4" 1" PIECES/BOX 40110200 40210200 40310200 € 10 10 10 DESCRIPTION ARTICLE 1/2" 3/4" 1" 40120200 40220200 40320200 PIECES/BOX € 10 10 10 N.O. STANDARD ZONE VALVES • Normally open in A. 2 ways - Without run-end micro: 3 wires DESCRIPTION 1/2" 3/4" 1" 2 ways - With run-end micro: 5 wires ARTICLE PIECES/BOX 30110200NA 30210200NA 30310200NA € 10 10 10 DESCRIPTION 1/2" 3/4" 1" ARTICLE 30120200NA 30220200NA 30320200NA PIECES/BOX € 10 10 10 M-M STANDARD ZONE VALVES 2 ways - Without run-end micro: 3 wires M-M DESCRIPTION 3/4" 1" 160 Tel.: +34 943 80 94 80 3 ways - Without run-end micro: 3 wires M-M ARTICLE PIECES/BOX 30610200 30710200 Fax: +34 943 80 52 41 € 10 10 DESCRIPTION 3/4" 1" www.orkli.com ARTICLE 40610200 40710200 PIECES/BOX 10 10 € NON DETACHABLE ZONE VALVES improvements SOLAR ZONE VALVES • More robust transmission • To be used in solar system primary circuits. • Fluid temperature -20ºC - 160ºC. • Fluid: water with glicol up to 50%. • Normally closed in A. 2 ways - Without run-end micro: 3 wires ARTICLE 30112200 30212200 30312200 PIECES/BOX € 10 10 10 DESCRIPTION 3 ways - Without run-end micro: 3 wires DESCRIPTION 1/2" 3/4" 1" ARTICLE 1/2" 3/4" 1" 30122200 30222200 30322200 PIECES/BOX € 10 10 10 3 ways - With run-end micro: 5 wires ARTICLE 40112200 40212200 40312200 PIECES/BOX € 10 10 10 DESCRIPTION ARTICLE 1/2" 3/4" 1" 40122200 40222200 40322200 PIECES/BOX € Zone 1/2" 3/4" 1" 05 valves DESCRIPTION 2 ways - With run-end micro: 5 wires 10 10 10 M-M SOLAR ZONE VALVES 2 ways - With run-end micro: 5 wires M-M 2 ways - Without run-end micro: 3 wires M-M DESCRIPTION 3/4" 1" ARTICLE 30612200 30712200 PIECES/BOX € DESCRIPTION 3 ways - Without run-end micro: 3 wires M-M DESCRIPTION 3/4" 1" ARTICLE 1" 10 10 30722200 PIECES/BOX € 10 3 ways - With run-end micro: 5 wires M-M ARTICLE 40612200 40712200 PIECES/BOX 10 10 € DESCRIPTION 1" Tel.: +34 943 80 94 80 ARTICLE 40722200 Fax: +34 943 80 52 41 PIECES/BOX € 10 www.orkli.com 161 ZONE VALVES DETACHABLE ZONE VALVES The new Orkli zone valves have a connector to make it easier for the installer to make the electrical connection and disconnection. Also, LEDs on the motorised part indicate the position/ operating status of the valve at all times. improvements • More robust transmission STANDARD ZONE VALVES NORMALLY CLOSED IN A • Motor valve "All-Nil". • Option with aluminium cover by special order. • Hysteresis motor 230V 50Hz. • Cable length 60 cm. • Option with 24V 50Hz motor by special order. • F-F / M-M option upon request. • Spring return. • NOTE: All items ordered that are not listed in this catalogue will have a price • Actuator that can be removed without having to empty the installation. increase of 5%. 2 ways - Without run-end micro: 3 wires DESCRIPTION 2 ways - Without run-end micro: 3 wires with PLUG-IN ARTICLE 1/2" 3/4" 1" PIECES/BOX 60114200 60214200 60314200 € 10 10 10 3/4" with PLUG-IN 2 ways - With run-end micro: 5 wires DESCRIPTION PIECES/BOX 60124200 60224200 60324200 € 10 10 10 PIECES/BOX 70114200 70214200 70314200 € 10 10 10 1/2" 3/4" 1" 162 Tel.: +34 943 80 94 80 DESCRIPTION 3/4" with PLUG-IN 3 ways - With run-end micro: 5 wires DESCRIPTION ARTICLE PIECES/BOX € 60228200 60226200 € 10 10 3 ways - Without run-end micro: 3 wires with PLUG-IN ARTICLE 1/2" 3/4" 1" PIECES/BOX 10 DESCRIPTION 3/4" with PLUG-IN 3/4" with PLUG-IN and LED's 3 ways - Without run-end micro: 3 wires DESCRIPTION ARTICLE 60218200 2 ways - With run-end micro: 5 wires with PLUG-IN and LED's ARTICLE 1/2" 3/4" 1" DESCRIPTION ARTICLE PIECES/BOX 70218200 10 ARTICLE PIECES/BOX € 3 ways - With run-end micro: 5 wires with PLUG-IN and LED's ARTICLE PIECES/BOX 70124200 70224200 70324200 Fax: +34 943 80 52 41 € 10 10 10 DESCRIPTION 3/4" with PLUG-IN 3/4" with PLUG-IN and LED's www.orkli.com 70228200 70226200 10 10 € DETACHABLE ZONE VALVES STANDARD ZONE VALVES NORMALLY CLOSED IN A Important information for replacement: The new actuator model will only be compatible with the new valve part model. It will not be compatible with the previous model. The reason for this is that the valve/actuator part movement transmission has been modified to achieve a more robust product. DESCRIPTION ARTICLE 39104000 39204000 39304000 PIECES/BOX € 10 10 10 DESCRIPTION ARTICLE 1/2" 3/4" 1" 49104000 49204000 49304000 PIECES/BOX € 10 10 10 Zone 1/2" 3/4" 1" 3 ways - Body valve. NEW MODEL 05 valves 2 ways - Body valve. NEW MODEL Actuator. NEW MODEL DESCRIPTION Without micro With micro Actuator. NEW MODEL ARTICLE 50014200 50024200 PIECES/BOX € 10 10 DESCRIPTION 2 ways - Body valve. PREVIOUS MODEL DESCRIPTION 1/2" 3/4" 1" ARTICLE 39100000 39200000 39300000 ARTICLE Without micro and with PLUG-IN With micro and with PLUG-IN With micro, PLUG-IN and LED's 50018200 50028200 50026200 PIECES/BOX € 10 10 10 3 ways - Body valve. PREVIOUS MODEL PIECES/BOX € 10 10 10 DESCRIPTION 1/2" 3/4" 1" ARTICLE 49100000 49200000 49300000 PIECES/BOX € 10 10 10 Actuator. PREVIOUS MODEL DESCRIPTION Without micro With micro ARTICLE 50011200 50021200 PIECES/BOX € 10 10 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 163 ZONE VALVES DETACHABLE ZONE VALVES STANDARD ZONE VALVES NORMALLY OPEN IN A 2 ways - Without run-end micro: 3 wires 2 ways - Without runend micro: 3 wires with PLUG-IN DESCRIPTION ARTICLE 1/2" 3/4" PIECES/BOX 60114200NA 60214200NA € 10 10 3/4" with PLUG-IN 2 ways - With run-end micro: 5 wires ARTICLE 60218200NA PIECES/BOX € 10 2 ways - With run-end micro: 5 wires with PLUG-IN and LED's DESCRIPTION 1/2" 3/4" DESCRIPTION ARTICLE PIECES/BOX 60124200NA 60224200NA € 10 10 DESCRIPTION ARTICLE PIECES/BOX 3/4" with PLUG-IN 60228200NA 10 3/4" with PLUG-IN and LED's 60226200NA 10 € UNITED KINGDOM AND IRELAND STANDARD ZONE VALVES 2 ways - With run-end micro DESCRIPTION 2 ways - With run-end micro, PLUG-IN and LED's ARTICLE U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" PIECES/BOX 60424600 60524600 60824600 60924600 € 10 10 10 10 DESCRIPTION U.K. model Ø22 with PLUG-IN U.K. model Ø22 with PLUG-IN and LED's U.K. model Ø28 with PLUG-IN U.K. model Ø28 with PLUG-IN and LED's ARTICLE 60528600 60526600 60428600 60426600 PIECES/BOX € 10 10 10 10 2 ways - With microswitch DESCRIPTION U.K. model Ø28 Ireland model 1" 3 ways - Mid-Position, all-mid-nil motor valve: 5 wires DESCRIPTION U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" 164 Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX 70454600 70554600 70854600 70954600 Fax: +34 943 80 52 41 ARTICLE PIECES/BOX 60444600 60844600 10 10 ARTICLE PIECES/BOX € 3 ways - Mid-Position, all-mid-nil motor valve: 5 wires with PLUG-IN and LED's € 10 10 10 10 DESCRIPTION U.K. model Ø22 with PLUG-IN U.K. model Ø22 with PLUG-IN and LED's U.K. model Ø28 with PLUG-IN U.K. model Ø28 with PLUG-IN and LED's www.orkli.com 70558600 70556600 70458600 70456600 10 10 10 10 € DETACHABLE ZONE VALVES UNITED KINGDOM AND IRELAND STANDARD ZONE VALVES Important information for replacement: The new actuator model will only be compatible with the new valve part model. It will not be compatible with the previous model. The reason for this is that the valve/actuator part movement transmission has been modified to achieve a more robust product. U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" ARTICLE 39404000 39504000 39804000 39904000 PIECES/BOX € 10 10 10 10 DESCRIPTION Actuator. NEW MODEL DESCRIPTION Without micro With micro Microswitch Mid-position U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" ARTICLE 50014600 50024600 50044600 50054600 PIECES/BOX € 10 10 10 10 DESCRIPTION ARTICLE 39400000 39500000 39800000 39900000 With micro With microswitch Mid-position ARTICLE Without micro and with PLUG-IN With micro and with PLUG-IN With micro, plug-in and LED's Mid-position with PLUG-IN Mid-position with PLUG-IN and LED's PIECES/BOX € 10 10 10 10 50018600 50028600 50026600 50058600 50056600 PIECES/BOX € 10 10 10 10 10 3 ways - Body valve. PREVIOUS MODEL PIECES/BOX € 10 10 10 10 DESCRIPTION ARTICLE U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" Actuator. PREVIOUS MODEL DESCRIPTION 49404000 49504000 49804000 49904000 Actuator. NEW MODEL 2 ways - Body valve. PREVIOUS MODEL DESCRIPTION ARTICLE U.K. model Ø28 U.K. model Ø22 Ireland model 1" Ireland model 3/4" Zone DESCRIPTION 3 ways - Body valve. NEW MODEL 05 valves 2 ways - Body valve. NEW MODEL 49400000 49500000 49800000 49900000 PIECES/BOX € 10 10 10 10 Syncron motor ARTICLE 50021600 50041600 50051600 PIECES/BOX 10 10 10 € DESCRIPTION 240 V 24V Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX F-7204 F-7214 - Fax: +34 943 80 52 41 www.orkli.com € 165 ZONE VALVES DETACHABLE ZONE VALVES USA - CANADA ZONE VALVES 2 ways - Without run-end micro 2 ways - With run-end micro • Motor valve "All-Nil". • Motor valve "All-Nil". • Hysteresis motor 24V. • Hysteresis motor 24V. • Cable length 60 cm. • Cable length 60 cm. • Option with 120 V motor by special order. • Option with 120 V motor by special order. • Valve normally closed. • Valve normally closed. • UL Recognized Component to U.S. and Canadian safety • UL Recognized Component to U.S. and Canadian safety requirements. requirements. • Inverted flare thread. • Inverted flare thread. • 100 cm cable option upon request. • 100 cm cable option upon request. • NPT and welding thread upon request. • NPT and welding thread upon request. • Plastic cover upon request. • Plastic cover upon request. • Valve normally open upon request. • Valve normally open upon request. • Cooper Sweat (welding) upon request. • Cooper Sweat (welding) upon request. DESCRIPTION ARTICLE 1/2" PIECES/BOX 68110200 € 10 DESCRIPTION 1/2" ARTICLE 68120200 PIECES/BOX € 10 3 ways - Without run-end micro 3 ways - With run-end micro • Motor valve "All-Nil". • Motor valve "All-Nil". • Hysteresis motor 24V. • Hysteresis motor 24V. • Cable length 60 cm. • Cable length 60 cm. • Option with 120 V motor by special order. • Option with 120 V motor by special order. • UL Recognized Component to U.S. and Canadian safety • UL Recognized Component to U.S. and Canadian safety requirements. requirements. • Inverted flare thread. • Inverted flare thread. • 100 cm cable option upon request. • 100 cm cable option upon request. • NPT and welding thread upon request. • NPT and welding thread upon request. • Plastic cover upon request. • Plastic cover upon request. DESCRIPTION 1/2" 166 Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX 78110200 Fax: +34 943 80 52 41 € 10 DESCRIPTION 1/2" www.orkli.com ARTICLE 78120200 PIECES/BOX 10 € DETACHABLE ZONE VALVES USA - CANADA ZONE VALVES 2 way - Body valve DESCRIPTION 3 way - Body valve ARTICLE 1/2" 38100000 PIECES/BOX € DESCRIPTION 10 ARTICLE 1/2" 48100000 PIECES/BOX € 10 Motor part metallic cover DESCRIPTION ARTICLE With microswitch (3 wires, 2+1 earth) With microswitch (5 wires, 4+1 earth) 58010200 58020200 PIECES/BOX € 10 10 Zone 05 valves HYDRAULIC CHARACTERISTICS 1000 900 800 700 600 d.p. (mmca) 500 400 2 ways ½" 2 ways ¾" 300 2 ways 1" 200 3 ways ½" 3 ways ¾" 100 3 ways 1" 0 30 60 100 200 300 400 600 800 1000 1200 1400 1600 1800 2000 2200 2400 2600 2800 3000 3200 3400 3600 3800 4000 4200 4400 4600 4800 5000 Flow (l/h) Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 167 06 Valves and safety groups Safety valves Safety groups Safety group kit Blister packs safety groups Safety units supplied on “trays Compensation valves Valves and 06 safety groups Accessories VALVES AND SAFETY GROUPS SAFETY VALVES SET AT 3 BAR RADIATORS • There are models for pressures from 2,5K - • There are models for pressures from 2,5K - 10K (on order basis). 10K (on order basis). DESCRIPTION 1/2” (NF) F-F 1/2” (NF) with input F-F 1/2” (NF) with manometer F-F 3/4” F-F 3/4” with input F-F 3/4” with manometer F-F ARTICLE PIECES/BOX 17003-00 17004-00 17004-01 13130 13230 13330 50 50 50 50 50 50 € DESCRIPTION 1/2” (NF) M-F 1/2” (NF) with input M-F 1/2” (NF) with manometer M-F 3/4” M-F 3/4” with input M-F 3/4” with manometer M-F ARTICLE PIECES/BOX 17005-00 17055-00 17017-00 13430 13530 13630 50 50 50 50 50 50 € SET AT 7 BAR DOMESTIC WATER • There are models for pressures from 2,5K - 10K (on order basis). DESCRIPTION 1/2” F-F 1/2” with input F-F 1/2” with manometer F-F 3/4” F-F 3/4” with input F-F 3/4” with manometer F-F ARTICLE PIECES/BOX 17011-00 17034-00 17030-00 13170 13270 13370 50 50 50 50 50 50 € • There are models for pressures from 2,5K - 10K (on order basis). DESCRIPTION 1/2” M-F 1/2” with input M-F 1/2” with manometer M-F 3/4” M-F 3/4” with input M-F 3/4” with manometer M-F ARTICLE PIECES/BOX 17023-00 17018-01 17018-02 13470 13570 13670 50 50 50 50 50 50 ARTICLE PIECES/BOX 17175-00 17176-00 17177-00 17178-00 17179-00 50 50 50 50 50 € SOLAR • Safety valve for solar installation primary circuits. • Suitable for working with 50% water-glycol mixture. • Maximum operating temperature: 160ºC. • Solar safety valve certification: TÜV SV 07 2012 • SOL • 50 • Consult for other setting options. DESCRIPTION 1/2” F - 3/4" F (3 bar) 1/2” F - 3/4" F (4 bar) 1/2” F - 3/4" F (6 bar) 1/2” F - 3/4" F (8 bar) 1/2” F - 3/4" F (10 bar) 170 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € Safety Group The features of this easier-to-install safety unit are improved thanks to its new innovative design and the use of materials guaranteeing both higher performance and greater reliability, which provides the Domestic Hot Water installation with an additional guarantee. Valves and 06 safety groups Installation advantages Vertical assembly 1 3 Horizontal assembly ASSEMBLY CHANGEABLE ORIENTATION. The new safety group incorporates a system that enables the orientation to be changed, horizontally right and left, and vertically. 2 4 REMOVABLE. The design, which is more functional and advanced, enables the safety valve to be removed easily and quickly. TWO IN ONE. The fact that it is easy to remove enables a standard version group to be converted into a Teflon-coated version, by just changing the safety valve. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 171 VALVES AND SAFETY GROUPS SAFETY GROUPS did you know...? Teflon guarantees a double insulation effect, preventing impurities and scale from accumulating on the safety units while providing insulation and avoiding electrolysis phenomena caused by currents in the electric water heater installations? KUATRO STANDARDS SERIES KUATRO TEFLON COATED SERIES • Set at 7 bar. • Set at 7 bar. • Featuring: • Featuring: - Locking tap. - Locking tap. - Purging or vacuum device. - Purging or vacuum device. - Antireturn device. - Antireturn device. • Removable safety valve. • Removable safety valve. • Horizontal and vertical orientation. • Horizontal and vertical orientation. • Easily convertible into a Teflon-coated model. DESCRIPTION Kuatro safety groups Kuatro safety valves ARTICLE PIECES/BOX 21170KU 17196-00 20 20 € DESCRIPTION Kuatro safety groups Kuatro safety valves ARTICLE PIECES/BOX 22170KU 17197-00 20 20 ARTICLE PIECES/BOX € Safety groups KUATRO with socket DESCRIPTION Standard Teflon 21170KUT 22170KUT € 10 10 STANDARDS SERIES 172 Straight orientation - vertical connection Elbow orientation - horizontal connection • Set at 7 bar. • Set at 7 bar. • Featuring: • Featuring: - Locking tap. - Locking tap. - Purging or vacuum device. - Purging or vacuum device. - Antireturn device. - Antireturn device. DESCRIPTION ARTICLE PIECES/BOX 1/2" (3/4 with assembly cover) 3/4" 1/2" (3/4 with assembly cover) plastic drain 3/4" plastic drain 21470 21170 21470P 21170P 20 20 20 20 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com DESCRIPTION ARTICLE PIECES/BOX 3/4" plastic drain 21670P 20 € SAFETY GROUPS TEFLON COATED SERIES Straight orientation - vertical connection Elbow orientation - horizontal connection • Set at 7 bar. • Set at 7 bar. • Featuring: • Featuring: - Locking tap. - Locking tap. - Purging or vacuum device. - Purging or vacuum device. - Antireturn device. - Antireturn device. DESCRIPTION ARTICLE PIECES/BOX 1/2" (3/4 with assembly cover) 3/4" 1/2" (3/4 with assembly cover) plastic drain 3/4" plastic drain 22270 22170 22270P 22170P 20 20 20 20 € DESCRIPTION ARTICLE PIECES/BOX 3/4" plastic drain 1" plastic drain 22670P 22570P 20 20 ARTICLE PIECES/BOX 21670PT 20 ARTICLE PIECES/BOX 21170PR 10 € WITH AN INPUT FOR A MIXER VALVE Standards Teflon coated • Set at 7 bar. • Set at 7 bar. • Featuring: • Featuring: - Locking tap. - Locking tap. - Purging or vacuum device. - Purging or vacuum device. - Antireturn device. • Elbow orientation also available. • With a 3/4" loose nut for mixer valve. • With a 3/4" loose nut for mixer valve. Valves and • Elbow orientation also available. 06 safety groups - Antireturn device. DESCRIPTION 3/4" straight orientation ARTICLE PIECES/BOX 21170PT 20 € DESCRIPTION 3/4" straight orientation € SAFETY UNIT ADAPTED FOR THE 3/4" WATER HEATER DESCRIPTION 3/4" Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 173 VALVES AND SAFETY GROUPS SAFETY GROUPS SAFETY GROUP KIT did you know…? ... IT’S ALL ADVANTAGES? 1 2 MA > Easy to install: requires no installation connectors. X > Comfort: a large hot water reserve is available in the boiler. 4 > Safety: No risk of burns, thanks to the mixing valve. > Better hygiene: there is no risk of bacteria as the temperature of the stored water falls to below 60º. 3 1. Thermostatic valve 2. Safety unit 3. Siphon 4. Flexible tube • Fitted with: • Fitted with: - Safety group with input. - Safety group with input. - Mixer valve. - Drainage pipe. - Syphon. - Accessories for copper pipe Ø 16. - Flexible pipe. - Syphon. - Flexible pipe. improvements DESCRIPTION Safety group kit 174 Tel.: +34 943 80 94 80 improvements ARTICLE PIECES/BOX 29170PK 1 Fax: +34 943 80 52 41 € DESCRIPTION Safety kit www.orkli.com ARTICLE GS1113000 PIECES/BOX 1 € SAFETY GROUPS 1/2" MODEL SOLAR Straight orientation • Set at 7 bar. • Set at 7 bar. • Featuring: - Locking tap. • Featuring: - Locking tap. - Purging or vacuum device. - Purging or vacuum device. - Antireturn device. - Antireturn device. • To be used in solar system primary circuits. • AISI 302 stainless steel valve spring. • Chemical-nickel treated brass valve shaft. • To be assembled outside. • Special plastic components for UV rays. DESCRIPTION ARTICLE 1/2" 1/2" + diffuser unit DESCRIPTION 3/4" 3/4" with adaptor to 1/2" ARTICLE 24170 24470 PIECES/BOX 21270 21271 PIECES/BOX € 20 20 € 20 20 Note: Same discount as components for solar heating systems section. BLISTER PACKS Safety unit with siphon Valves and 06 safety groups Safety unit improvements DESCRIPTION GS ¾” standard, straight in blister pack GS ¾” teflon-coated, straight in blister pack GS ¾” standard, elbow in blister pack GS ¾” teflon-coated, elbow in blister pack ARTICLE PIECES/BOX 21170PB 22170PB 21670PB 22670PB - € DESCRIPTION ARTICLE GS ¾” standard, straight + siphon in blister pack 21170PSB GS ¾” teflon-coated, straight + siphon in blister pack 22170PSB GS ¾” standard, elbow + siphon in blister pack 21670PSB GS ¾” teflon-coated, elbow + siphon in blister pack 22670PSB Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 PIECES/BOX € - www.orkli.com 175 VALVES AND SAFETY GROUPS did you know...? WE SERVE IT UP ON A TRAY? Orkli offers the option of safety units supplied on “trays”. Trays DESCRIPTION 3/4" Straight drain 3/4" Straight drain ARTICLE PIECES/BOX 21170PSK 22170PSK 24 24 ARTICLE PIECES/BOX € COMPENSATION VALVES • Designed to work outdoors. • Stainless steel spring. • Plastic lever adapted to resist UV rays. DESCRIPTION 1/2" - 7K 3/4" - 7K ARTICLE 10576 10577 PIECES/BOX € 120 90 DESCRIPTION 1/2" - 7K 3/4" - 7K 1/2" - 10K 3/4" - 10K DESCRIPTION 1/2" - 9 K 176 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 10559 10561 10558 10560 ARTICLE 10573 € 120 90 120 90 PIECES/BOX € ACCESSORIES Syphons Manometers • Radial excentric input. improvements DESCRIPTION ARTICLE PIECES/BOX NF Certified E-12236 20 € DESCRIPTION ARTICLE PIECES/BOX 0-4 kg/cm2 0-10 kg/cm2 E-4944 E-4945 - ARTICLE PIECES/BOX D-10618 D-10619 - € Drain DESCRIPTION € Valves and 06 safety groups Straight drain Square drain Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 177 07 energy efficiency Climate control Thermostats and chronothermostats Thermostat and chronothermostats by radio frecuency External climate control Thermocyclic control 07 control Climate Climate control accessories CLIMATE CONTROL THERMOSTATS AND CHRONOTHERMOSTATS Digital Mechanical • Screen indicating room temperature • Temperature adjustable from 10-30ºC. and set temperature. • Ready for fixing on the wall. • Temperature adjustable from 5º - 35ºC. • Powered by two alkaline batteries (1,5 V type LR6) (included). • Low battery indicator. • Ready for fixing on the wall. DESCRIPTION ARTICLE PIECES/BOX Ambient thermostat - ON/OFF Summer - winter ambient thermostat 547000 547001 40 40 € DESCRIPTION ARTICLE PIECES/BOX Ambient thermostat - ON/OFF Summer - winter ambient thermostat 547005 547006 40 40 € CS7 series SR series • Temperature adjustable form 5º - 30ºC. • Connections unit: for connection of thermoelectric heads and pump. • Swing 0,5 ºC. • Powered by two alkaline batteries (1,5V type LR6) (included). • Ready for fixing on the wall. DESCRIPTION ARTICLE PIECES/BOX Weekly chronothermostat 579000 - € DESCRIPTION ARTICLE PIECES/BOX Connection box Thermostat Cover for public spaces E-25228 E-25229 E-25601 1 1 1 € THERMOSTAT AND CHRONOTHERMOSTATS BY RADIO FRECUENCY CS7 series SR series • Temperature adjustable form 5º - 30ºC. • Connections unit: for connection of thermoelectric heads and pump. • Swing 0,5 ºC. • Powered by two alkaline batteries (1,5V type LR6) (included). • Ready for fixing on the wall. 180 DESCRIPTION ARTICLE PIECES/BOX Weekly chronothermostat + radio receiver kit 578155 5 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 € www.orkli.com DESCRIPTION ARTICLE PIECES/BOX Connection box Thermostat Cover for public spaces E-25230 E-25231 E-25601 1 1 1 € EXTERNAL CLIMATE CONTROL Central heating unit External sensor • Includes card and wall assembly case. DESCRIPTION ARTICLE PIECES/BOX Digital station with more than 1 circuit control Digital station unit with control of central heating/cooling 588253 588252 1 1 € Pocket for pulse sensor DESCRIPTION ARTICLE PIECES/BOX 2 meters, IP65-NTC 1% - 10K OHM-25ºC E-18901 1 DESCRIPTION ARTICLE PIECES/BOX Thermosound TRP 150 Ø 6,5 x 36 mm. - wire 2 m. E-19452 1 DESCRIPTION ARTICLE PIECES/BOX To prevent steam E-22106 1 € Pulse sensor • Also valid for the return. DESCRIPTION ARTICLE PIECES/BOX Ø 7 x 8 x47, nut 1/2" NPT 555001 1 € Ambient sensor € Anti-steam sensor DESCRIPTION ARTICLE PIECES/BOX Enclosure IP20, Sensor NTC 1% - 10K OHM - 25ºC 576808 1 € € Relay module for dehumidifier control DESCRIPTION ARTICLE PIECES/BOX Relay module for dehumidifier control E-24593 1 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 07 control A dehumidifier can be controlled via the central regulation unit by fitting this accessory. Climate did you know...? € 181 CLIMATE CONTROL THERMOCYCLIC CONTROL did you know...? Is the thermocyclic regulation of an indoor room based on a totally new regulation process? It calculates in advance when the actuator or heater should be switched on or off using a totally new, unique regulation process that learns the properties of each heating system in order to anticipate them and use them for its calculations. The system begins to learn from the first time it is switched on, to provide maximum comfort in every area and every room. It was patented on 27 January 2000 and successfully introduced in the European market. The tests carried out at the Institute of Thermodynamics and Technical Equipment for Buildings of the Dresden University of Technology were confirmed in practice: the energy savings were greater than with traditional thermostat regulation. By means of microoscillations of ± 0.15 ºC, the regulator rapidly configures the desired indoor temperature. white: Theoretical temperature yellow: Real temperature red: Heating switched on. And how does it actually work? In a room with doors and windows and with people inside it, it is almost impossible for a constant temperature to be maintained. Energy is continually supplied and lost: the doors and windows are opened and closed, people enter and leave the room, heaters are switched on or candles are lit, the sun shines through the windows or it rains. The real indoor temperature varies continually: it is not stable. The daily heating phases intensify these temperature oscillations, often by several degrees. This inevitably gives rise to an unpleasant ambient temperature. On the other hand, these temperature changes contain information on the system constants and the atmospheric conditions (the orientation of the room, climate, use). This is how the thermocyclic regulation makes its calculations: it uses this information and controls the oscillations to very fine values. It continually evaluates the movements it has learnt and defined, and then regulates them in real time. The user configures the desired comfort temperature using the central control unit or the interior units, decides how long the night period will last or how the system will be used during the weekend, and the regulation process is performed on the basis of these. No further configuration is necessary. 182 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com THERMOCYCLIC CONTROL DESCRIPTION ARTICLE PIECES/BOX Central unit E-18650 1 DESCRIPTION ARTICLE PIECES/BOX Local unit RS E-18652 1 DESCRIPTION ARTICLE PIECES/BOX Regulator VR E-18654 1 DESCRIPTION ARTICLE PIECES/BOX Wireless ambient temperature sensor E-24872 1 € € € € DESCRIPTION ARTICLE PIECES/BOX Chronothermostats RG E-18651 1 DESCRIPTION ARTICLE PIECES/BOX Switch 4 channels ST E-18653 1 DESCRIPTION ARTICLE PIECES/BOX Transformer TR E-18655 1 DESCRIPTION ARTICLE PIECES/BOX Wireless receiver E-24873 1 DESCRIPTION ARTICLE PIECES/BOX TCS safety contact thermostat 543461 50 DESCRIPTION ARTICLE PIECES/BOX 3/4" 1 1/4" E-18603 E-18604 15 10 € € € € CLIMATE CONTROL ACCESSORIES Thermoelectric head Safety contact thermostat • Easy to install: first screw the nut onto the valve, and then screw on the head until you hear a click. The cable does not obstruct assembly. ARTICLE F-9996 E-16898 E-18127 CT410800 PIECES/BOX Climate NC 230V M28x1,5 head M28x1,5 NC 24V head M28x1,5 NC 230V head with micro M30x1,5 NC 230V head 07 control DESCRIPTION € € 24 24 24 24 Differential pressure valve improvements Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € 183 08 Security products Security 08 products Security products for water and gas leaks SECURITY PRODUCTS FOR WATER AND GAS LEAKS Alarm system: Mixed Gas Detector and CO • Gas detection in accordance with UNE 50194. Alarm system: Home system gas electrovalve control and CO • CO detection in accordance with UNE-EN 50291. • Gas detection in accordance with UNE 50194. • Alarm light and beeper. • Alarm light and beeper. • TEST/RESET button. • TEST/RESET button. • System failure indicator. • System failure indicator. • Free voltage relay output N.A. 3 Amp. • Free voltage relay output N.A. 3 Amp. • Surface installation. • Installation in universal 60x60 mm box. DESCRIPTION Gas detector GLP DESCRIPTION Mixed gas detector ARTICLE PIECES/BOX DGM-300AK ARTICLE PIECES/BOX DGP-300AK € 1 € 1 Alarm system: Gas Detector GLP Alarm system: Home system water leak detector • Gas detection in accordance with UNE 50194. • Alarm light and beeper. • Alarm light and beeper. • TEST/RESET button. • TEST/RESET button. • Surface installation. • System failure indicator. • Free voltage relay output N.A. 3 Amp. • Installation in universal 60x60 mm box. DESCRIPTION Water leak detector (surface) DESCRIPTION Natural gas detector ARTICLE PIECES/BOX DGN-300AK ARTICLE PIECES/BOX SA 200-S 1 ARTICLE PIECES/BOX € € 1 Water electrovalve Home system water electrovalve control • On light (green). • Activated light (red). • Surface installation. DESCRIPTION DESCRIPTION ARTICLE PIECES/BOX Home system water electrovalve control (surface) EA 200-S € 1 Note: domotic elements option on request. 186 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com Gas electrovalve N.O. 220 V V 1/2" standards resetting EV GAS 1/2" Water electrovalve N.O. 220 V 3/4" standards resetting EV AGUA 3/4" 1 1 € 09 Thermocouples 09 Thermocouples THERMOCOUPLES Universal thermocouple Threaded head thermocouple DESCRIPTION DESCRIPTION ARTICLE 600 mm. 900 mm. 1200 mm. Special propane thermocouple 900 mm. T100257600P T100196900P T1002571200P T100844900P PIECES/BOX € 300 300 300 300 Wire interrupted thermocouple DESCRIPTION ARTICLE Wire interrupted thermocouple Wire interrupted thermocouple PIECES/BOX € - Smooth head thermocouple PIECES/BOX T100116 320 T100116 600 T100116 100 € - Thick head pilot thermocouple ARTICLE PIECES/BOX € - PIECES/BOX Interruption extension T30020 - DESCRIPTION DESCRIPTION Normal head pilot thermocouple Interrupted thermocouple Interrupted thermocouple ARTICLE € ARTICLE T100979320 T100979600 T100979850 PIECES/BOX € - Normal head pilot thermocouple T100223500 DESCRIPTION - DESCRIPTION Threaded head M8 thick head 320 mm. Threaded head M8 thick head 600 mm. Threaded head M8 thick head 850 mm. Thick head pilot thermocouple DESCRIPTION € Threaded head thermocouple ARTICLE Smooth head M9 thick head 320 mm Smooth head M9 thick head 600 mm. Smooth head M9 thick head 1000 mm. T1A1Z1200 T1A1Z1500 T1A1Z220 T1A1Z320 T1A1Z400 T1A1Z800 T1A1Z900 PIECES/BOX Interruption extension 16400223 1640062 DESCRIPTION Threaded head thermocouple 1200 mm Threaded head thermocouple 1500 mm Threaded head thermocouple 220 mm Threaded head thermocouple 320 mm Threaded head thermocouple 400 mm Threaded head thermocouple 800 mm Threaded head thermocouple 900 mm ARTICLE ARTICLE T10098900 PIECES/BOX € - Pilot thermocouple ARTICLE PIECES/BOX T30095610 € - DESCRIPTION Pilot thermocouple M8 ARTICLE T100146450 PIECES/BOX € - Water heater thermocouple DESCRIPTION Water heater thermocouple 188 Tel.: +34 943 80 94 80 ARTICLE PIECES/BOX T10082300 Fax: +34 943 80 52 41 € - DESCRIPTION Water heater thermocouple www.orkli.com ARTICLE T100110423 PIECES/BOX - € 10 10 parts Spare Spare parts SPARE PARTS VALVES AND FITTINGS FOR RADIATORS Protection handle Two-pipe lever • Driving-wheel featurin cap. DESCRIPTION ARTICLE PIECES/BOX White handle 3/8” - 1/2” Stopper for handle ref. F-10081 F-10081 E-9229 - € DESCRIPTION M28 M30 Handle screw ARTICLE PIECES/BOX D-2608 D-10109 - ARTICLE PIECES/BOX F-8439 F-8440 - ARTICLE PIECES/BOX € Single-pipe lever DESCRIPTION ARTICLE PIECES/BOX 3/8” - 1/2” - 3/4" bitube Zinc -single pipe white handle Anti oxidation proof single pipe black handle F-10083 F-7869 F-3734 - € DESCRIPTION White Black € Nut Series D valve adjustable tool * For 3/4" sleeve and 1/2" sleeve monotube and 3/4" sleeve bitube. DESCRIPTION ARTICLE Series D valve adjustable tool PIECES/BOX E-19783 € DESCRIPTION Nut for 3/8" tube (5/8" thread) Nut for 1/2" tube (3/4" thread) Nut for 3/4" tube (1" thread) - Stopper F-7895 F-7894 F-7900* € - Sleeve • O-ring supplied. DESCRIPTION Lockshield 3/8" - 1/2" nickel plated Wall lockshield ARTICLE PIECES/BOX F-5124 F-9596 - € Pipe, shank and straight pipe DESCRIPTION ARTICLE Pipe 3/4” Pipe 1/2” Pipe 1/2" (Ref. 52390, 52290, 52490, 52590) Shank 3/4” (0,2 meters) Shank 3/4" (1 meters) 1/2" extension pipe (0,425 meters) 190 Tel.: +34 943 80 94 80 PIECES/BOX E-1901 E-3259 E-23545 F-4382 23805009 E-16099 Fax: +34 943 80 52 41 € - DESCRIPTION ARTICLE PIECES/BOX 3/8” Sleeve with seals 3/8” Without locking seal to radiator 1/2” Sleeve with seals 1/2” Without locking seal to radiator 1/2” - 3/8” Sleeve with seals 1/2” - 3/8” Without locking seal 1/2” - 3/4” (4V) Sleeve with seals 3/4” Sleeve with seals with seals for monotube and bitube F-7883 E-16338 F-7882 E-16324 F-8822 E-16401 E-23758 - E-24922 - ARTICLE PIECES/BOX F-7818 F-9210 F-9950 - Outlet terminal plug DESCRIPTION Seal Interior stopper Stopper www.orkli.com € € ZONE VALVES Syncron motor DESCRIPTION ARTICLE PIECES/BOX F-7204 F-7214 - DESCRIPTION ARTICLE PIECES/BOX - E-19902 - DESCRIPTION ARTICLE PIECES/BOX For flow regulator M24 x 1,5 For lockshield and valve M24 x 1,5 E-23307 E-23276 - 240 V 24V € MANIFOLD COMPONENTS Flow regulator Plastic inspection box support DESCRIPTION ARTICLE PIECES/BOX 1/2" 3/8" E-15915 E-23374 - € Purging device for modular manifolds ARTICLE PIECES/BOX D-11129 - € Covers for manifold inspection boxes € Connectors for manifold inspection boxes DESCRIPTION ARTICLE PIECES/BOX 335 mm. 415 mm. 515 mm. 615 mm. E-24781 E-24782 E-24783 E-24784 - € DESCRIPTION ARTICLE PIECES/BOX ¾" valve and lockshield ¾" flow regulator 1" valve and lockshield 1" flow regulator 1 ¼" valve and lockshield 1 ¼" flow regulator E-24796 E-24802 E-24797 E-24804 E-24798 E-24806 - € Spare - Adapter connector for modular manifolds Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 191 10 parts DESCRIPTION € SPARE PARTS SAFETY GROUPS AND VALVES Safety valve for Teflon-coated KUATRO Safety valves for Standard KUATRO DESCRIPTION ARTICLE KUATRO safety group PIECES/BOX 17199 € - DESCRIPTION KUATRO safety group ARTICLE 17200 PIECES/BOX € - Drain DESCRIPTION Straight drain Square drain ARTICLE PIECES/BOX D-10618 D-10619 - € VALVES FOR WATER HEATERS CONNECTION TAURO Heating valve Domestic hot water valve DESCRIPTION 1/2 M - 1/2 H with loose nut ARTICLE PIECES/BOX 91199-01 80 € DESCRIPTION 3/4 M - 3/4 H with loose nut ARTICLE PIECES/BOX 91399-00 70 ARTICLE PIECES/BOX 91097-00 80 € Gas valve DESCRIPTION 1/2 M - 1/2 H with loose nut 192 Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com € CONDITIONS GENERAL PURCHASING CONDITIONS The commercial relationships formed between Orkli and the customers will be conditioned by the points that follow: > The prices indicated in our lists are understood: material, packing and sitted in our factory in Ordizia. > At the time of order, the minimum quantities for each product determined in the lists must be respected. > Payment: 60 days net monthly. > No returns will be accepted without Orkli previous knowledge and authorisation. > The increasing of the prices will be informed by Orkli to the clients in a reasonable lapse of time, and, in any case, will be valid from the date indicated in our price list. > Orkli reserves the right to cancel any order in case the purchaser had previously unfulfilled any previous contract. > Delays by supplying, being the cause not due directly to Orkli will not be enough cause to cancel an order or delay payment. > Orkli does not accept returns of customised products. > Orkli reserves the right of ownership of any material sent but not paid for. > Orkli will not accept any material supplied that is outside the guarantee period, or which has been modified in any way. > Failures due to the transport will not be attributed to Orkli. 3 YEAR WARRANTY This is to certify that Orkli Sociedad Cooperativa warrants to the first purchaser only, the products manufactured by it to be free from defects in materials and workmanship, when properly maintained, and under normal use and service. Orkli Sociedad Cooperativa’s sole obligation under this warranty shall be limited to the repair or replacement, at its option, of any defective part of said product which is the result of defective material and/or defective workmanship of parts furnished by Orkli Sociedad Cooperativa. This warranty will expire thirty-six (36) months from date of delivery, and repairs under this warranty shall be at repairs facilities designated by Orkli Sociedad Cooperativa. Transportation expenses to the repair facility are to be borne by the Purchaser. The warranty herein is expressly in lieu of any and all other warranties, expressed or implied. The warranty herein does not apply to, and Orkli Sociedad Cooperativa makes no warranties, expressed or implied, with respect to any goods which after delivery hereunder have been repaired or altered by anyone other than has been authorized and approved by Orkli Sociedad Cooperativa, unless, in manufacturer’s reasonable opinion, such repairs are in no way responsible for the condition complained of. Customer and Manufacturer agree that customer’s sole remedy for any defects in new goods delivered hereunder, whether customer’s claim arises under the warranty set forth above, or otherwise, shall be limited to the repair or replacement at manufacturer’s option within three (3) years after delivery of such goods to the first purchaser, of any defective goods, of which notice of the defects is given by Customer to Manufacturer immediately after such defect is or ought to have been discovered and which goods are returned to Manufacturer within ten (10) days after Manufacturer requests their return for inspection and/or repair or replacement. Orkli Sociedad Cooperativa Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 193 C OMMERCIAL > SALES OFFICES NETWORK ORKLI, U.K. LTD. Simon Baker - Orkli (UK) Ltd. Unit 1,Trident Court One Oakcroft Road Chessington Surrey KT9 1BD Tel.: +44 (0) 203 044 2992 Fax.: +44 (0) 203 044 2701 e-mail: [email protected] Deutschland Brazil Orkli do Brasil Av. José Benassi, 300 Galpão 03 – FAZGRAN SP - CEP: 13213-085 Pq. Industrial - Jundiaí Fazgran Tel.: +55 (11) 4525-0190 Fax: +55 (11) 4525-2482 E-mail: [email protected] Orkli Deutschland GmbH Steinlachstraße 109 D-72116 Mössingen / Talheim Tel.: + 49 (0) 7473/ 92407-0 Fax.: + 49 (0) 7473 / 92407-28 e-mail: [email protected] Argentina Czech Republic Uriarte Taldea S.A. Defensa 2616 Panam. y 197 El Talar de Pacheco - Tigre CP 1618 Tel. + 54 11 47269585 Fax. + 54 11 47632400 e-mail: [email protected] Belgium Impex Chaussée de Vleurgat, 184 1000 BRUXELLES - BRUSSEL Belgique Tel. + 32 026 473 275 e-mail: [email protected] 194 Tel.: +34 943 80 94 80 Italy Jiri Prec - Orkli,S.Coop. Prumyslova 3143/5 79601 Prostejov - Rep. Checa Tel.: +420 602 748 159 Fax: +420 582360800 e-mail: [email protected] France Pierre-Jean Dupouy Boite postale Nº 8 47310 Brax / France Tel. - Fax: +33 05 53 68 34 15 Portable: +33 06 08 01 71 29 e-mail: [email protected] Fax: +34 943 80 52 41 www.orkli.com Orkli Italia, S.R.L. Vía Roma 108 20060 Cassina de Pecchi (MI) Tel.: + 39 02 953 034 25 Fax.: + 39 02 953 012 98 e-mail: [email protected] Portugal Antonio da Mota Pascoal Crêspos - Britêlo 4890-264 Celorico de Basto Tel./Fax. + 351 - 255323619 Móvil: + 351 - 963211744 e-mail: [email protected] Russia MCC Rusia Bolotnaia naberezhnaya, 15, block 1 119072 Moscow - Rusia Tel.: +7 495 957 3557 Fax: +7 495 957 3560 e-mail: [email protected] USA Mikel BASURTO Tel.: 00 1 647 680 2612 e-mail: [email protected] ORKLI, A TAILOR-MADE COMPANY WITH THE SUPPORT OF A LARGE GROUP: MONDRAGON ORKLI started to produce and market central heating and domestic appliance components in 1982. Thanks to the company’s experience, it offers the widest range of components for central heating, domestic hot water, water heating and domestic appliances. This has been achieved to a large extent due to the professionalism of its workforce and the support of a top level European business Group (MCC), with offices and production plants all over the world. Within the Mondragón, ORKLI forms part of MONDRAGÓN COMPONENTES. WORLDWIDE PRESENCE The company is organised into 3 global business units, based on customer type: ORKLI’s extensive range of products provides access to practically the whole world market. The company exports more than 80% of its sales, and is one of the leading companies in its sector in Europe. > Thermoelectric safety Thermoelectric safety systems aimed at component manufacturers for gas application in the domestic appliance world. > Central heating and domestic hot water, underfloor heating systems and components for solar systems. Aimed at satisfying the needs of the central heating sector through wholesalers, distributors, prescriber warehouses, etc. > ORKLI is part of MONDRAGÓN, a business group made up of 218 companies and bodies divided into three sectorial groups: Financial, Industrial and Distribution, together with Research and Training areas. With plants abroad, it operates its own network of offices and agents in the five continents. Thanks to the quality of its products and sustained growth, this international position achieved by ORKLI is a determining factor in terms of the company’s future size and development. Water heating Products aimed at boiler, water heater and electric water heater manufacturers. ORKLI’s location in Ordizia (Gipuzkoa) provides the company with convenient access to major communication networks. A motorway ensures a rapid link with Bilbao international airport, as well as the airports in VitoriaGasteiz, San Sebastián, Pamplona and Biarritz (France), in addition to the seaports of Bilbao and Pasajes. Only a company like ORKLI, backed by the quality of its products and exclusive service, can fully guarantee the development of its own projects and those of its customers. Tel.: +34 943 80 94 80 Fax: +34 943 80 52 41 www.orkli.com 195 notes 196 Tel.: +34 943 80 94 51 80 Fax: +34 943 80 52 41 www.orkli.com GENERAL CATALOGUE 2012 UNDERFLOOR HEATING-COOLING SOLAR SYSTEMS HEATING and PLUMBING GENERAL CATALOGUE 2012 ORKLI, S. Coop. Ctra. Zaldibia, s/n / E - 20240 Ordizia (Gipuzkoa) Tel.: + 34 943 80 94 80 / Fax: + 34 943 80 52 41 E-mail: [email protected] www.orkli.com www.orkli.com
Similar documents
ECO Radiator - Stelrad Radiators
energy and efficient heating and cooling technologies, our buildings can emit up to 60% less CO2. The European Union helps carry the load by gradually making energy consumption standards stricter. ...
More information