IC-M88 Service Manual - R

Transcription

VHF MARINE TRANSCEIVER
iC- m88
INTRODUCTION
This service manual describes the latest service information for
the IC-M88 VHF MARINE TRANSCEIVE R at the time of
publication.
Model Version
IC-M88
Symbol
FM I / S
Battery pack
USA
NO
BP-227
USA-1
YES
BP-227FM
SEA
NO
BP-227
U.S.A.
S.E. Asia
To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER
NEVER connect the transceiver to an AC outlet or a DC
power supply that uses more than 8.3 V. This will ruin the
transceiver.
DO NOT expose the transceiver to rain, snow or any
liquids.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100
mW) to the antenna connector. This could damage the
transceiverís front end.
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1. 10-digit order numbers
2. Component part number and name
3. Equipment model name and unit name
4. Quantity required
<SAMPLE ORDER>
1110002750 S.IC TA7S01F
IC-M88
8210019100 2600 Front panel IC-M88
MAIN UNIT 1 piece
CHASSIS
5 pieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1. Make sure the problem is internal before disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is disconnected from its power source.
3. DO NOT force any of the variable components. Turn them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the transceiver is defective.
6. DO NOT transmit power into a signal generator or a sweep generator.
7. ALWAYS connect a 40 dB or 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when
using such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
TABLE OF CONTENTS
SECTION 1
SPECIFICATIONS
SECTION 2
INSIDE VIEWS
SECTION 3
DISASSEMBLY INSTRUCTIONS
SECTION 4
CIRCUIT DESCRIPTION
4-1
RECEIVER CIRCUITS ................................................................................................... 4 - 1
4-2
TRANSMITTER CIRCUITS ............................................................................................ 4 - 2
4-3
PLL CIRCUITS................................................................................................................. 4 - 3
4-4
POWER SUPPLY CIRCUITS ......................................................................................... 4 - 3
4-5
CPU PORT ALLOCATIONS ........................................................................................... 4 - 4
SECTION 5
ADJUSTMENT PROCEDURES
5-1
PREPARATION................................................................................................................ 5 - 1
5-2
SOFTWARE ADJUSTMENT ........................................................................................... 5 - 4
SECTION 6
PARTS LIST
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
SECTION 8
SEMI-CONDUCTOR INFORMATION
SECTION 9
BOARD LAYOUTS
9-1
CHARGER UNIT ............................................................................................................. 9 - 1
9-2
VR UNIT .......................................................................................................................... 9 - 1
9-3
CONNECTOR UNIT ........................................................................................................ 9 - 1
9-4
MAIN UNIT....................................................................................................................... 9 - 2
9-5
LOGIC UNIT .................................................................................................................... 9 - 4
SECTION 10
BLOCK DIAGRAM
SECTION 11
VOLTAGE DIAGRAM
SECTION 1 SPECIFICATIONS
GENERAL
• Frequency coverage
: TX: 156.025–157.425 MHz, RX: 156.050–163.275 MHz
TX/RX: 146.000–174.000 MHz
• Number of free channels
: 22 channels
• Type of emission
: 16K0G3E (Wide; 25 kHz)
16K0F3E (Wide; 25 kHz), 8K50F3E (Narrow; 12.5 kHz)
• Antenna connector
: SMA (50 Ω)
• Power supply requirement
: BP-227/FM (7.2 V DC, negative ground)
• Current drain (approx.)
: Transmit
Receive
• Usable temperature range
at
at
at
at
at
High (5.0 W)
Middle (3.0 W)
Low1 (1.0 W)
maximum audio
stand-by
[MARINE]
[LMR]
[MARINE]
[LMR]
1.6 A
1.2 A
0.7 A
200 mA
Less than 120 mA
: –20˚C to +60˚C; –4˚F to +140˚F
–30˚C to +60˚C; –22˚F to +140˚F
[MARINE]
[LMR]
• Dimensions (projections not included) : 62(W) × 97(H) × 39(D) mm; 27⁄16(W) × 313⁄16(H) × 117⁄32(D) in.
• Weight (with antenna, BP-227/FM)
: 280 g; 97⁄8 oz (approx.)
TRANSMITTER
• RF output power (with BP-227/FM)
: 5 W / 3 W / 1 W (High / Middle / Low)
• Modulation system
: Variable reactance frequency modulation
• Maximum frequency deviation
: ±5.0 kHz (Wide)
±5.0 kHz (Wide), ±2.5 kHz (Narrow)
• Frequency error
: ±5.0 ppm
• Spurious emissions
: –70 dBc
• Adjacent channel power
: 70 dB
70 dB (Wide), 60 dB (Narrow)
• Audio harmonic distortion
: 10% at 60% deviation
• FM Hum and noise
: 40 dB
• Limiting charact modulation
: 60–100% of maximum deviation
• Ext. microphone connector
: 9-pin multi connector/2.2 kΩ
[MARINE]
[LMR]
[MARINE]
[LMR]
[MARINE]
[LMR]
RECEIVER
• Receive system
: Double conversion superheterodyne system
• Intermediate frequencies
: 1st
2nd
31.05 MHz
450 kHz
• Sensitivity
: 0.25 µV typical at 12 dB SINAD
• Squelch sensitivity
: 0.35 µV typical at threshold
• Adjacent channel selectivity
: 70 dB typical
70 dB typical (Wide), 60 dB typical (Narrow)
• Spurious response rejection
: 70 dB typical
• Intermodulation rejection ratio
: 70 dB typical
• Hum and noise
: 40 dB
• Audio output power (at 7.2 V DC)
: 350 mW typical at 10% distortion with an 8 Ω load
• Ext. speaker connector
: 9-pin multi connector/8 Ω
Specifications are measured in accordance with TIA/EIA-603.
All stated specifications are subject to change without notice or obligation.
1-1
[MARINE]
[LMR]
[MARINE]
[LMR]
VHF MARINE CHANNEL LIST
Channel No.
USA INT CAN
Channel No.
USA INT CAN
156.050
160.650
21A
01
01
156.050
156.050
02
02
156.100
160.700
03
03
156.150
160.750
156.150
156.150
23A
156.200
160.800
24
24
156.200
156.200
25
25
156.250
160.850
26
05A
156.250
156.250
06
156.300
156.300
156.350
160.950
07A
156.350
156.350
61
01A
03A
04
04A
05
05A
06
06
Frequency (MHz)
Transmit
Receive
07
07A
08
08
08
156.400
156.400
09
09
09
156.450
156.450
10
10
10
156.500
156.500
11
11
11
156.550
156.550
12
21A
Frequency (MHz)
Transmit
Receive
157.050
157.050
Channel No.
USA INT
73
73
156.675
156.675
157.100
161.700
74
74
156.725
156.725
22A
157.100
157.100
77*1
77
156.875
156.875
23
157.150
161.750
78
156.925
161.525
157.150
157.150
156.925
156.925
24
157.200
161.800
156.975
161.575
25
157.250
161.850
156.975
156.975
26
26
157.300
161.900
157.025
161.625
27
27
27
157.350
161.950
157.025
157.025
28
28
28
157.400
162.000
157.075
161.675
60
60
156.025
160.625
157.075
157.075
156.075
160.675
157.125
161.725
156.075
156.075
157.125
157.125
156.125
160.725
157.175
161.775
156.125
156.125
83A
157.175
157.175
156.175
160.775
84
157.225
161.825
156.175
156.175
84A
157.225
157.225
64
156.225
160.825
85
157.275
161.875
64A
157.275
157.275
157.325
161.925
157.325
157.325
157.375
161.975
157.375
157.375
157.425
162.025
157.425
157.425
22
22A
23
61A
61A
62
62A
63
78A
79
79A
80
80A
81
81A
82
82A
83
12
12
156.600
156.600
13*2
13
13*1
156.650
156.650
14
14
14
156.700
156.700
156.225
156.225
85A
156.750
156.750
65
156.275
160.875
86
15*2 15*1 15*1
16
17*1
63A
64
64A
16
16
156.800
156.800
65A 65A 65A
156.275
156.275
86A
17
17*1
156.850
156.850
66
156.325
160.925
87
156.900
161.500
66A 66A
156.325
156.325
87A
156.900
156.900
67*2
67
156.375
156.375
88
156.950
161.550
68
68
156.425
156.425
88A
156.950
156.950
69
69
156.475
156.475
157.000
161.600
70*3
70*3
156.525
156.525
157.000
157.000
71
71
156.575
156.575
157.050
161.650
72
72
156.625
156.625
18
18A
18A
19
19A
19A
20
20*1
20
20A
21
21
Frequency (MHz)
Transmit
Receive
84
85
86
87
88
*1 Low power only, *2 Momentary high power, *3 Receive only
NOTE: Channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be used by the general public in USA waters.
WX CHANNEL LIST
Weather
channel
Frequency (MHz)
Transmit
Receive
Weather
channel
Frequency (MHz)
Transmit
Receive
WX01
Receive only
162.550
WX06
Receive only
162.500
WX02
Receive only
162.400
WX07
Receive only
162.525
WX03
Receive only
162.475
WX08
Receive only
161.650
WX04
Receive only
162.425
WX09
Receive only
161.775
WX05
Receive only
162.450
WX10
Receive only
163.275
1-2
SECTION 2
INSIDE VIEWS
• LOGIC UNIT
Bottom view
*: Located in another side of
this point.
AF mute circuit
Q441* : 2SC4116
Q442* : CPH3403
Q443 : CPH3403
Q444 : DTC144EU
IN/EXT microphone switch
(Q461, Q462: UN911H)
EEPROM
(IC591*: HN58X2416TI)
Microphone amplifier
(IC471: NJM2904V)
CPU
(IC661: µPD780316GC-511-9EB)
AF mute
(IC481: TC4W66FU)
S5V regulator
(Q561: 2SA1588)
M5V regulator
Q551: 2SB1132
Q552: XP6501
Q553: DTC144EU
• MAIN UNIT
Bottom view
Top view
Antenna switching circuit
D131, D151: 1SV307
D152: MA77
RF amplifier
(Q165: 3SK294)
APC control
(IC141: TA75S01F)
Power amplifier
(Q111: RD07MVS1)
Bandpass filter
(FI211: FL-355)
Pre-drive amplifier
(Q101: RD01MUS1)
T5V regulator
(Q323: 2SA1588)
PLL IC
(IC1: MB15A02PFV)
R5V regulator
(Q322: 2SA1588)
Reference frequency
crystal
(X1: CR664A;
15.300 MHz)
V5V regulator
(Q321: 2SA1588)
VCO circuit
FM IF IC
(IC231:
TA31136FN)
1st Mixer
(Q191: 3SK299)
IF amplifier
(Q211: 2SC4215)
AF mute
(IC281: TC4W66FU)
D/A converter
(IC251:
M62363FP-650C)
2-1
SECTION 3
DISASSEMBLY INSTRUCTIONS
1. Removing the chassis panel
q Remove nut A.
w Unscrew 2 screws B (2 × 8 mm, black) and 3 screws
(2 × 4 mm, black) from the chassis.
e Take off the chassis in the direction of the arrow.
C
C
B
y
e
NOTE: * Tighten the screws in order of a number (q–y)
when assembling.
C
r
w
q
A
Chassis
C
t
2. Removing the LOGIC unit.
3. Removing the MAIN unit
q Unplug the cable from J281 on the MAIN unit to separate
the LOGIC unit
w Separate the front panel from the chassis in the direction
of the arrow.
e Unsolder 2 leads of the speaker and connector unit (9
points).
r Unscrew 3 screws D (2 × 4 mm, silver) to separate the
front panel.
q Unsolder 4 leads of contact spring and antenna connector
(1 point).
w Unscrew 6 screws D (2 × 4 mm, silver) to separate the
chassis.
NOTE: * Tighten the screws in order of a number (q–y)
when assembling.
NOTE: * Tighten the screws in order of a number (z–c)
when assembling.
E
D
J281
z
c
w
t
r
Chassis
VR unit
W801
J281
Unsolder
(A contact spring
and antenna connector)
Unsolder
(A SP and
connector unit)
Front panel
MAIN UNIT
LOGIC UNIT
D
x
e
y
q
E
3-1
SECTION 4 CIRCUIT DESCRIPTION
The 1st IF signal is applied to a 2nd mixer section of the
FM IF IC (IC231, pin 16). The signal is then mixed with a
2nd LO signal for conversion into a 450 kHz 2nd IF signal.
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
(MAIN UNIT)
The antenna switching circuit functions as a low-pass filter
while receiving and as resonator circuit while transmitting.
The circuit does not allow transmit signals to enter receiver
circuits.
IC231 contains the 2nd mixer, limiter amplifier, quadrature
detector and active filter circuits. A 30.6 MHz 2nd LO
signal is produced at the PLL circuit using the reference
frequency.
Received signals from the antenna connector pass through
the low-pass filter (L131, L132, C131–C136) and antenna
switching circuit (D151, D152). The filtered signals are then
applied to the RF amplifier circuit (Q165).
The 2nd IF signal from the 2nd mixer (IC231, pin 3)
passes through ceramic filters (FI231, FI232) to remove
unwanted heterodyned frequencies. It is then amplified at
the limiter amplifier section (IC231, pin 5) and applied to
the quadrature detector section (IC231, pins 10 and 11) to
demodulate the 2nd IF signal into AF signals.
4-1-2 RF AND 1ST MIXER CIRCUITS (MAIN UNIT)
The 1st mixer circuit converts the received signals to a
fixed frequency of the 1st IF signal with a PLL output
frequency. By changing the PLL frequency, only the desired
frequency will be passed through a pair of crystal filters at
the next stage of the 1st mixer.
4-1-4 AF CIRCUIT (MAIN AND LOGIC UNITS)
AF signals from the FM IF IC (IC231, pin 9) are fed to the
analog switch (IC282).
The AF signals (detected signals) passes through the AF
mute switch (IC281A, pins 2 and 1) via “DET” signal, and
are then applied to the analog switch (IC282, pin 1). The
signals are then applied to the low-pass filter (IC261B,
C266, C267, R270–R272).
The signals from the antenna switching circuit are passed
through the 2-stage bandpass filters (D154, D155, L154,
L155) and amplified at the RF amplifier (Q165). The
amplified signals are passed through another 2-stage
bandpass filters (D181, D182, L181, L182), and then
applied to the 1st mixer circuit (Q199).
The filtered AF signals are applied to and adjusted audio
level at the [VOL] control (VR unit; R801) via the “VOLIN”
signal. The level controlled signals are passed through the
AF mute switch (LOGIC unit; Q411) which is controlled by
“AFMS” signal from the CPU (IC661, pin 84). The passed
signals are applied to the AF power amplifier (IC421, pin
4), and then output to the internal speaker or [EXT SP] jack
after being passed through the de-emphasis circuit (R411,
C413) to obtain the –6 dB/octave frequency characteristics
The filtered signals are mixed at the 1st mixer (Q199) with
a 1st LO signal coming from the PLL circuit to produce
a 31.05 MHz 1st IF signal. The 1st IF signal is passed
through a pair of crystal filter (FI211) and is then amplified
at the IF amplifier (Q211).
4-1-3 2ND IF AND DEMODULATOR CIRCUITS
(MAIN UNIT)
The 2nd mixer circuit converts the 1st IF signal to a 2nd IF
signal. A double conversion superheterodyne system (which
converts receive signal twice) improves the image rejection
and obtain stable receiver gain.
• 2ND IF AND DEMODULATOR CIRCUITS
Q231
Q232
C238
R240
R241
C239
8 R239
2nd IF filters
450 kHz
Noise
detector
2nd
Mixer
IF amp.
"SQLOUT" signal to the D/A
convertor IC (IC251, pin 1)
FM
detector
R242
10
11
12
R231
R232
X231
450 kHz
14
16
IC231 TA31136FN(D)
"IF" (1st IF signal: 31.05 MHz)
from RF unit, Q211
"NOISV" signal to the CPU (pin 32)
"RSSIV" signal to the CPU (pin 33)
C232
C244
X1
15.3 MHz
Noise
comp.
RSSI
9
C242
30.6 MHz
2
17
16
PLL IC
2 Q221
IC1
5 Fl232 Fl231 3
7
Active
filter
"SQCON" signal to the D/A
AF signal "DET"
C243
W/N
SW
R5V
4-1
4-1-5 SQUELCH CIRCUIT
(MAIN AND LOGIC UNITS)
4-2-2 MODULATION CIRCUIT (MAIN UNIT)
The modulation circuit modulates the VCO oscillating signal
(RF signal) using the microphone audio signals.
The noise squelch circuit cuts out AF signals when no RF
signals are received. By detecting noise components in the
AF signals, the squelch circuit switches the AF mute switch.
The audio signals “MOCON” change the reactance of D39
to modulate an oscillated signal at the TX VCO circuit (Q51,
D35–D38, L34, L51, C32, C33, C52–C54). The oscillated
signal is amplified at the buffer-amplifiers (Q61, Q62).
A portion of the AF signals divided by C242 from the
FM IF IC (IC231, pin 9) are applied to the D/A converter
(IC251, pin 2) to adjust amplitude. The signals from the
D/A converter (IC251, pin 1) are applied to the active filter
section (IC231, pin 8, R239–R241, C237, C238). The active
filter section amplifies and filters noise components. The
filtered signals are applied to the noise detector section
and output from IC231 (pin 14) as the “NOISV” signal.
4-2-3 PRE-DRIVE/POWER AMPLIFIER CIRCUITS
(MAIN UNIT)
The signal from the VCO circuit passes through the
transmit/receive switching circuit (D91, D92) and is applied
to the buffer-amplifier (Q91). The amplified signal is
amplified by the pre-driver (Q101) and the power amplifier
(Q101) to obtain 5 W of RF power (at 7.2 V). The amplified
signal passes through the antenna switching circuit (D131),
and low-pass filter (L131, L132, C131–C136) and is then
applied to the antenna connector.
The “NOISV” signal from IC231 (pin 14) is applied to the
CPU (LOGIC unit; IC611, pin 32). The CPU compares the
set squelch level voltage and “NOISV” signal voltage to
control the squelch output.
The bias current of the buffer amplifier (Q91), pre-driver
(Q101) and power amplifier (Q111) is controlled by the
APC circuit to stabilize the output power.
4-2 TRANSMITTER CIRCUITS
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
(LOGIC AND MAIN UNITS)
The microphone amplifier circuit amplifies audio signals
with +6 dB/octave pre-emphasis characteristics from the
microphone to a level needed for the modulation circuit.
4-2-4 APC CIRCUIT (MAIN UNIT)
The APC circuit provides stable output power from the
power amplifier even when the input voltage or temperature
changes, and, selects HIGH, MIDDLE, LOW or EXTRA
LOW output power. The APC circuit consists of a power
detector and APC control circuits.
• In case of the internal microphone
The AF signals from the internal microphone (MC461) is
applied to the microphone amplifier (IC471a, pin 6) via the
“INMIC” signal.
• POWER DETECTOR CIRCUIT (MAIN UNIT)
The power detector circuit (D132) detects the transmit
output power level and converts it to DC voltage as the
“TDETV” signal. The detected signal is applied to the APC
control circuit.
• In case of external microphone
The AF signals from the external microphone (CP458) is
applied to the microphone amplifier (IC471a, pin 6) via the
“EXTMIC” signal.
• APC CONTROL CIRCUIT (MAIN AND LOGIC UNITS)
The “TDETV” signal from the power detector circuit is
applied to the CPU (LOGIC unit; IC661, pin 31) to control
the input voltage of the buffer amplifier (Q91), pre-driver
(Q101) and power amplifier (Q111). When the output power
changes, the CPU (LOGIC unit; IC661) outputs APC control
signal to the D/A converter (IC190). And then “T1CON”
signal from the D/A converter controls the APC controller
(IC141) to provide stable output power.
The amplified signals are passed through the pre-emphasis
circuit (R463, C463) and are then applied to the AF mute
switch (IC481a, pin 1) via the “MICO” signal after being
passed through the another microphone amplifier (IC471b,
pins 2 and 1).
The AF signals are amplified again at the limiter-amplifier
(IC491a, pin 2) and then passed through the low-pass filter
(IC491b, pins 6 and 7). The filtered audio passes through
the analog swtich (MAIN unit; IC251, pins 4 and 3), and is
then applied to the MAIN unit as the “MOCON” signal.
• APC CIRCUIT
VCC
antenna
T5V
RF signal
from PLL
Q91
Buffer
amp.
Q101
Pre-drive
amp.
Q111
Power
amp.
D131
ANT
SW
LPF
S5V
"TXMS" signal from the
expander IC (IC341, pin 12)
"T1CON" signal from the D/A
Power detector
circuit (D132)
3
Q141
1
IC141
APC control circuit
"TDETV" to the CPU
(LOGIC unit; IC661, pin 31)
4-2
4-3 PLL CIRCUIT (MAIN UNIT)
4-4 POWER SUPPLY CIRCUITS
4-3-1 GENERAL
VOLTAGE LINES
The PLL circuit provides stable oscillation of the transmit
frequency and receive 1st LO frequency. The PLL output
compares the phase of the divided VCO frequency to the
reference frequency. The PLL output frequency is controlled
by the divided ratio (N-data) of a programmable divider. IC1
is a PLL IC which controls both VCO circuit for TX and RX.
LINE
HV
The PLL circuit, using a one chip PLL IC (IC1), directly
generates the transmit frequency and receive 1st IF
frequency with VCOs. The PLL sets the divided ratio
based on serial data from the CPU on the LOGIC unit and
compares the phases of VCO signals with the reference
oscillator frequency. The PLL IC detects the out-of-step
phase and output from the pin 6 for TX and RX. The
reference frequency (15.3 MHz) is oscillated at X1.
The phase detector compares the input signal with a
reference frequency, and then outputs the out-of-phase
signal (pulse-type signal) from pin 6.
The pulse-type signal is converted into DC voltage (lock
voltage) at the loop filter (R17–R19, C16–C19), and then
applied to varactor diodes (TX; D35–D38, RX; D31–D34)
of the TX-VCO and RX-VCO to stabilize the oscillated
frequency.
VCC
CPU5V
Common 5 V converted from the VCC line by the
CPU5V regulator circuit (LOGIC unit; IC551).
The output voltage is applied to the CPU (LOGIC
unit; IC661), RESET circuit (LOGIC unit; IC581),
etc.
M5V
Common 5V converted from the VCC line by the
M5V regulator circuit (LOGIC unit; Q551–Q553).
The output voltage is applied to R5V, T5V, V5V and
S5V regulator circuits (LOGIC unit; Q322, Q323,
Q321 and Q561).
R5V
Receive 5V converted from the M5V line by the
R5V regulator circuit (MAIN unit; Q322).
The regulated voltage is applied to the 1st mixer
circuit (MAIN unit; Q191), RF and IF amplifiers
(MAIN unit; Q165, Q211).
T5V
Transmit 5V converted from the M5V line by the
T5V regulator circuit (MAIN unit; Q222).
The regulated voltage is applied to the buffer
amplifier (MAIN unit; Q91).
V5V
Common 5V converted from the M5V line by
the V5V regulator circuit (MAIN unit; Q321).
The regulated voltage is applied to the ripple
filter circuit (Q47).
S5V
Common 5V converted from the M5V line by the
S5V regulator circuit (LOGIC unit; Q561).
The regulated voltage is applied to the microphone
amplifier (LOGIC unit; IC471), limit amplifier
(LOGIC unit; IC491), LCD back light (LOGIC unit;
DS651–DS654), etc.
4-3-3 TX AND RX VCO CIRCUITS (MAIN UNIT)
The VCO circuit from Q41 (RX) and Q5 (TX) are buffer
amplified at the Q61 and Q62, and then sent to the TX/RX
swtich (D91, D92). The receive LO signal is applied to the
1st mixer circuit (Q191) through an attenuator (L203, R203
–R206, C202, C203), and the transmit signal is applied to
the buffer amplifier (Q91). A portion of the VCO output is
reapplied to the PLL IC (IC1, pin 8) via the Q71.
The voltage from the attached battery pack.
The same voltage as the HV line (battery
voltage) which is controlled by the power switch
(VR unit; [OFF/VOL] control).
The output voltage is applied to the pre-drive
(MAIN unit; Q101), power amplifier (MAIN unit;
Q111), CPU5V and M5V regulator circuits
(LOGIC unit; IC551 and Q551–Q553).
4-3-2 TX AND RX LOOP CIRCUITS (MAIN UNIT)
The generated signal at the TX-VCO circuit (Q51, D35
–D38, L34, L51, C32, C33, C52–C54) or RX-VCO (Q41,
D31–D34, L32, L41, C31, C41–C43) enters the PLL IC (IC1,
pin 8) and is divided at the programmable divider section
and is then applied to the phase detector section.
DESCRIPTION
• PLL CIRCUIT
RX VCO
S5V
Q82
Q81
VCOS
Q41, D31 D34
Buffer
TX VCO
Q61
VCO SWITCH
Loop
filter
FM
MOD.
D39
Q51, D35 D38
X1
15.3 MHz
2 2
Q221
1
Phase
detector
to the 1st mixer circuit
D92
Buffer
Q71
Programmable
counter
Programmable
divider
4-3
to transmitter circuit
Q62
IC1 MB15A02PFV
5
"2nd LO" signal (30.6 MHz)
to the FM IF IC (IC231, pin 2)
D91
Buffer
Prescaler
Shift register
LPF
8
11
10
9
PLSTBO
SDATAO
SCLKO
4-5 PORT ALLOCATIONS
4-5-1 CPU (LOGIC UNIT; IC661)
Pin
number
Port
name
1
BEEP
Description
Pin
number
Port
name
Description
79
STXMS
Outputs scrambler mute signal for the
AF mute circuit (IC481, pin 3).
Low : While scrambler is muting.
80
MICMS
Outputs mic mute signal for the AF
mute circuit (IC481, pin 7).
Low : While the microphone is
muting.
81
ISPMS
Outputs the internal speaker control
signal.
High : While the speaker is muting.
82
LDTFS
Outputs DTCS’s low-pass filter cut-off
frequency control signal.
Outputs beep audio signals.
2
VSSTB
Outputs strobe signals for the scrambler
IC (MAIN unit; IC381, pin 10).
3
EXSTB
Outputs strobe signals for the
expander IC (MAIN unit; IC341, pin 1).
4
DASTB
Outputs strobe signals for the D/A
converter (MAIN unit; IC251, pin 6).
5
PLSTB
Outputs strobe signals for the PLL IC
(MAIN unit; IC1, pin 11).
6
ERXDI
Input port for cloning signals.
7
ETXDO
Outputs cloning signals.
10
SDATA
Outputs serial data for PLL, scrambler
ICs, etc.
83
W/NS
Outputs Wide/Narrow control signal.
high : While Narrow is selected.
11
SCLK
O u t p u t s s e r i a l c l o ck fo r P L L ,
scrambler ICs, etc.
84
AFMS
Outputs the AF mute circuit control
signal.
High : The AF mute circuit is ON.
12
ESCK
Outputs clock signal for the EEPROM
(IC591, pin 6).
85
AFVS
Outputs AF amplifier’s power supply
control signal.
High : The AF amplifier is ON.
86
M5VS
Outputs M5V power supply control
signal.
Low : The common 5V is supplied.
87
S5VS
Outputs S5V power supply control
signal.
88
V5VS
Outputs V5V power supply control
signal.
89
R5VS
Outputs R5V power supply control
signal.
Low : While receiving.
90
T5VS
Outputs T5V power supply control
signal.
Low : While transmitting.
98
99
100
CENC1
CENC2
CENC3
Output DTCS/CTCSS wave form.
102
PTTIN
Input port for [PTT] swtich detection.
High : While [PTT] switch is pushed.
103
Input port for HM-138 (optional
speaker-microphone)’s [PTT] swtich
EPTTIN detection.
Low : While HM-138’s [PTT] switch
is pushed.
13
17
27
ESDA
I/O port for EEPROM data signal
(IC591, pin 5).
CSIFT
Outputs CPU clock shift signal.
High : While clock is shifted.
WDECV Input port for the WX tone detection.
28
WETIN
Input port for the transceiver’s internal
inundation detection.
29
EXTSV
Input port for the external terminal
connecting detection.
30
BATTV
Input port for the battery voltage
detection.
31
TDETV
Input port for transmit RF level
detection.
32
NOISV
Input port for noise level detection.
33
RSSIV
Input port for RSSI voltage level
detection.
34
LOINV
Input port for VCO lock voltage level
detection.
35
TEMPV
Input port for the transceiver’s internal
temperature detection.
36
CDECV
Input port for CTCSS/DTCS detection.
38
ATIS
46–48
COM0–
COM2
Output LCD common signals
51–70
SEG0–
SEG19
Output LCD segment signals.
104
BTYPE
75
76
CONT1
CONT2
Output LCD contrast control signals.
109
SQL
Input port for the [SQL] key.
Low : While [SQL] key is pushed.
77
78
LEDS1
LEDS2
Output LCD and key’s back light
dimmer control signal.
110
UP
Input port for the [UP] key.
Low : While [UP] key is pushed.
Outputs ATIS wave form.
4-4
Input port for the connecting battery
type detection.
Low : While using alkaline cells.
4-5-2 EXPANDER IC (MAIN UNIT; IC341)
CPU–Continued
Pin
number
Port
name
DOWN
Input port for the [DOWN] key.
Low : While [DOWN] key is pushed.
112
CH/WX
Input port for the [CH/WX] key.
Low : While [CH/WX] key is pushed.
113
16/9
Input port for the [16/9] key.
Low : While [16/9] key is pushed.
114
SCAN
Input port for the [SCAN] key.
Low : While [SCAN] key is pushed.
111
115
119
Pin
number
Description
H/L
Input port for the [H/L] key.
Low : While [H/L] key is pushed.
UNLK
Input port for the PLL unlock signal.
High : PLL lock voltage is unlocked.
Port
name
Description
5
SRXMS
Outputs the AF mute switch (IC281,
pin 3) control signal.
Low : While the scrambler decording
signal is muted.
6
DETMS
Outputs the AF mute swtich (IC281,
pin 7) control signal.signal.
Low : While AF signal is muted.
7
CKSIS
Outputs the scrambler IC’s clock shift
control signal.
High : While the clock is shifted.
11
ATTS
Outputs the RF attenuator control
signal.
High : While attenuator is ON.
12
TXMS
Outputs the TX mute swtich (Q141)
control signal.
Low : While receiving.
13
VCOS
Outputs the TX/RX VCO control
signal.
4-5-3 D/A CONVERTOR IC (MAIN UNIT; IC251)
4-5
Pin
number
Port
name
2
SQCON
3
MOCON Outputs modulatin level control signal.
10
DTCON
Outputs DTCS modulation balance
control signal.
11
FRCON
Outputs reference frequency level
control signal.
14
T1CON
Outputs bandpass filter1 tuned and
transmitting power control signals.
15
T2CON
Outputs bandpass filter2 tuned signal.
22
T3CON
23
T4CON
Description
Outputs squelch level control signal.
SECTION 5 ADJUSTMENT PROCEDURES
5-1 PREPARATION
When adjusting IC-M88, optional OPC-966 CLONING CABLE, optional RS-232C CABLE and optional CS-M88 adj ADJUSTMENT
SOFTWARE are required.
EQUIPMENT
GRADE AND RANGE
DC power supply
Output voltage
Current capacity
: 7.2 V DC
: 3 A or more
RF power meter
(terminated type)
Measuring range
Frequency range
Impedance
SWR
: 0.1–10 W
: 100–300 MHz
: 50 Ω
: Less than 1.2 : 1
Frequency counter
Digital multimeter
Frequency range
: 0.1–300 MHz
Frequency accuracy : ±1 ppm or better
Sensitivity
: 100 mV or better
Input impedance
EQUIPMENT
GRADE AND RANGE
FM deviation meter
Frequency range
Measuring range
: 30–300 MHz
: 0 to ±10 kHz
Audio generator
Frequency range
Measuring range
: 300–3000 Hz
: 1–500 mV
Frequency range
Output level
: 100–300 MHz
: 0.1 µV–32 mV
(–127 to –17 dBm)
Power attenuation
Capacity
: 40 dB or more
: 10 W or more
Standard signal
generator (SSG)
Attenuator
: 10 MΩ/DC or better
SYSTEM REQUIREMENTS
STARTING SOFTWARE ADJUSTMENT
• Microsoft® Windows® 95/98/ME
1. Connect IC-M88 and PC with the optional OPC-966 and
the RS-232C cable.
2. Boot up Windows®, and turn the transceiver power ON.
3. Click the program group ‘CS-M88 ADJ’ in the ‘Programs’
folder of the [Start] menu, then CS-M88 ADJ’s window is
appeared.
4. Click ‘Connect’ on the CS-M88 ADJ’s window, then
appears IC-M88’s up-to-date condition.
5. Set or modify adjustment data as desired.
ADJUSTMENT SOFTWARE INSTALLATION
1. Boot up Windows®.
- Quit all applications when Windows® is running.
2. Insert the cloning software CD-ROM into the appropriate
CD-ROM drive.
3. Select ‘Run’ from the [Start] menu.
4. Type the setup program name using the full path name,
then push the [Enter] key. (For example; D:\ setup)
5. Follow the prompts.
6. Program group ‘CS-M88 ADJ’ appears in the ‘Programs’
folder of the [Start] menu.
Microsoft and Windows are registered trademarks of
Microsoft Corporation in the U.S.A. and other countries.
Screen shots produced with permission from Microsoft
Corporation. All other products or brands are registered
trademarks or trademarks of their respective holders.
5-1
• CONNECTION
to the antenna connector
Attenuator
40 dB or 50 dB
FM
deviation meter
Standard signal generator
0.1 V to 32 mV
( 127 dBm to 17 dBm)
CAUTION:
DO NOT transmit while
SSG is connected to the
antenna connector.
RF power meter
0.1 10 W/50
Frequency
counter
Personal
computer
to an RS-232C port
Audio generator
SINAD meter
DB9 female plug
*OPC-966
(JIG CABLE)
RS-232C cable (straight)
Speaker (8 )
Add a jumper wire here
OPC-966
(Cloning cable)
PTTE
PTT
MIC
MICE
+
Audio generator
300 Hz to 3 kHz
AC
millivoltmeter
SP
SP+
+
5-2
• SCREEN EXAMPLE
CS-M88 ADJ Rev.1.0
File Option
COM 1: OPEN
2
Connect
Reload (F5)
Disp para
1
4
5
[A / D]
BATT :
NOIS :
SD
:
LVIN
:
TEMPS :
TXDET :
WET :
120
59
44
119
178
0
255
:
:
:
:
:
:
:
78h
3Bh
2Ch
77h
B2h
00h
FFh
[D / A]
FRQCON
T1/POW
T2
T3
T4
Dev
CTCS BL
SQL LEV
: 7.53 V
: 1.16 V
: 0.86 V
: 2.33 V
: 26.86 ’C
: 0.00 V
: 5.00 V
:
:
:
:
:
:
:
:
127
92
127
86
117
0
0
76
:
:
:
:
:
:
:
:
7Fh
5Ch
7Fh
56h
75h
00h
00h
4Ch
:
:
:
:
:
:
:
:
2.49 V
1.80 V
2.49 V
1.69 V
2.29 V
0.00 V
0.00 V
1.49 V
6
7
8
9
10
11
12
13
14
15
16
17
NOTE: The above values for settings are example only.
Each transceiver has its own specific values for each setting.
1 : Transceiver’s connection state
9 : Reference frequency
2 : Reload adjustment data
10 : RF output power
3 : Receive sensitivity measurement
11 : FM deviation
4 : Connected battery voltage
12 : Modulation balance
5 : PLL lock voltage
13 : Receive sensitivity (automatically)
6 : Dial mode select
14 : Receive sensitivity (manually)
7 : Operating channel select
15 : Squelch level (automatically)
8 : RF output power select
16 : Squelch level (manually)
17 : Adjustment items
5-3
3
5-2 SOFTWARE ADJUSTMENT
Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.
MEASUREMENT
ADJUSTMENT
ADJUSTMENT CONDITION
VALUE
ADJUSTMENT
UNIT
ADJUSTMENT
CONDITION
UNIT
LOCATION
PLL LOCK
VOLTAGE
1 • Operating channel : center frequency
• Receiving
MAIN Connect the digital multimeter to
1.5–3.0 V (Verify)
the check point LV.
• Connect the RF power meter or 50 Ω
dummy load to the antenna connector.
• Transmitting
1.8–3.3 V (Verify)
REFERENCE
FREQUENCY
Top Loosely couple the frequency
• Connect the RF power meter or 50 Ω panel c o u n t e r t o t h e a n t e n n a
dummy load to the antenna connector.
connector.
• Transmitting
160.000000 MHz
OUTPUT
POWER
• [H/L] switch
: High
• Transmitting
Top Connect the RF power meter to
panel the antenna connector.
5.0 W
2 • [H/L] switch
• Transmitting
: Mid
3.0 W
3 • [H/L] switch
• Transmitting
: Low
0.75 W
4 • [H/L] switch
• Transmitting
: Extra low
0.45
FM
DEVIATION
(Wide)
1 •
•
•
•
Operating channel : center frequency
Top Connect the FM deviation
Channel spacing
: Wide
panel meter to the antenna connector
[H/L] switch
: High
through the attenuator.
Connect the audio generator to the
[MIC] jack and set as:
1.0 kHz/200 mV rms.
• Set the FM deviation meter as:
HPF
: OFF
LPF
: 20 kHz
De-emphasis
: OFF
Detector
: (P–P)/2
• Transmitting
(Narrow)
2 • Channel spacing
• Transmitting
: Narrow
MODULATION
BALANCE
(Wide)
1 • Operating channel
• Channel spacing
• [H/L] switch
• Set the DTCS as
• Transmitting
: center frequency
: Wide
: High
: Code 007
(Narrow)
2 • Channel spacing
• Transmitting
: Narrow
±4.15–4.25 kHz
±2.00–2.10 kHz
Top Connect the FM deviation meter
panel with an oscilloscope to the
antenna connector through the
attenuator.
Set to flat wave
form
Set to flat wave
form
5-4
• MAIN UNIT TOP VIEW
LV
PLL lock voltage
check point
5-5
SOFTWARE ADJUSTMENT – continued
• Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.
• “SQUELCH LEVEL ADJUSTMENT” must be performed after “RX SENSITIVITY ADJUSTMENT” is finished.
• “SQUELCH LEVEL ADJUSTMENT” must be performed when “RX SENSITIVITY ADJUSTMENT” is adjusted.
ADJUSTMENT
ADJUSTMENT
ADJUSTMENT CONDITION
ADJUSTMENT
CONDITION
MEASUREMENT
UNIT
LOCATION
VALUE
VALUE
RX
Top Connect a SINAD meter with an Minimum distortion
1 • Operating frequency: center frequency
level
panel 8 Ω load to the [SP] jack.
SENSITIVITY
• Channel spacing
: Wide
[BPF T1]–[BPF T4]
• Connect a standard signal generator to
the antenna connector and set as:
Level
: 10 µV* (–87 dBm)
Modulation
: OFF
Deviation
: ±3.0 kHz
• Receiving
CONVENIENT: The BPF T1–BPF T4 can be adjusted automatically.
1: Set the cursor to “BPF ALL” on the adjustment program and then push [ENTER] key.
2: The connected PC tunes BPF T1–BPF T4 to peak levels.
or
1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.
2: Push [ENTER] key to start tuning.
3: Repeat w-1 and w-2 to perform additional BPF tuning.
SQUELCH
LEVEL
[SQL]
Top The “SQUELCH LEVEL” adjustment is adjusted by
1 • Operating frequency: center frequency
panel “ADJUSTMENT SOFTWARE”, automatically.
• Channel spacing
: Wide
• Connect a standard signal generator to
the antenna connector and set as:
Level
: 0.56 µV* (–112 dBm)
Modulation
: 1 kHz
Deviation
: ±3.0 kHz
• Receiving
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
5-6
SECTION 6
PARTS LIST
[LOGIC UNIT]
[VR UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
R801
7210003130 VAR
TP76N97N-13F-10KA-2497
W801
W802
8900011900 CBL
8900011910 CBL
8900012031 CBL
OPC-1192
OPC-1193
OPC-1231A
[US], [SEA]
[US1]
0910055622 PCB
0910055991 PCB
B 5892B
B 5982A
[US], [SEA]
[US1]
EP801
REF
NO.
H/V
M. LOCATION
[CONNECTOR UNIT]
REF
NO.
ORDER
NO.
H/V
M. LOCATION
DESCRIPTION
J851
6910014800 CNR
6910015030 CNR
IMSA-9230B-1-09Z133-T [US], [SEA]
IMSA-9230B-1-09Z135-T
[US1]
EP851
0910055631 PCB
0910055632 PCB
B 5893A
B 5893B
[US], [SEA]
[US1]
[LOGIC UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
H/V
M. LOCATION
IC421
IC471
IC481
IC491
IC551
IC581
IC591
IC661
IC681
1110001810
1110003800
1130007300
1110003800
1110005350
1110005770
1130010390
1140011150
1130007300
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
TA7368F (ER)
NJM2904V-TE1
TC4W66FU (TE12L)
NJM2904V-TE1
NJM2870F05-TE1
S-80942CNMC-G9C-T2
HN58X2416TI
µPD780316GC-511-9EB 2600A
TC4W66FU (TE12L)
B
B
B
B
B
B
T
B
B
24.8/41.8
46.2/7.1
26.1/8.6
6.5/4.7
12.6/39.7
51.3/41
51.2/40.6
36/24.7
43.1/12.7
Q411
Q431
Q432
Q441
Q442
Q443
Q444
Q461
Q462
Q501
Q531
Q532
Q551
1530003090
1520000450
1590001190
1530002850
1560001130
1560001130
1590000430
1590003430
1590003420
1590000430
1590001770
1530002850
1520000450
S.TR
S.TR
S.TR
S.TR
S.FET
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
2SC4213-B (TE85R)
2SB1132 T100 Q
XP6501-(TX) .AB
2SC4116-BL (TE85R)
CPH3403-TL
CPH3403-TL
DTC144EUA T106
UNR911HJ-(TX)
UNR911FJ-(TX)
DTC144EUA T106
XP1213 (TX)
2SC4116-BL (TE85R)
2SB1132 T100 Q
T
B
B
T
T
B
B
B
B
B
B
B
B
62.2/40.6
11.7/45.3
6.9/44.4
51.8/28.5
55/28
57.8/29.4
59.6/32.3
56.1/13.8
58.2/13.6
11.9/15.9
17.9/14.6
22/11.4
17.1/22.9
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
ORDER
NO.
DESCRIPTION
Q552
Q553
Q561
Q651
1590001190
1590000430
1510000670
1590001770
S.TR
S.TR
S.TR
S.TR
XP6501-(TX) .AB
DTC144EUA T106
2SA1588-GR (TE85R)
XP1213 (TX)
B
B
B
B
13.3/23.7
20.1/20.1
22/16
27.4/16.9
D451
D452
D453
D454
D581
D601
1730002360
1790000950
1790000950
1790000950
1790001250
1790000620
S.ZEN
S.ZEN
S.ZEN
S.ZEN
S.DIO
S.DIO
MA8062-M (TX)
MA8056-M (TX)
MA8056-M (TX)
MA8056-M (TX)
MA2S111-(TX)
MA77 (TX)
T
T
T
T
B
B
57/13.4
63.8/13.7
61.9/14
60/15.2
48.8/40.1
47.1/36.1
X601
6050011550 S.XTL
CR-747 (9.8304 MHz)
B
41.4/42.1
L421
6200010230 S.COL EXCCL3216U1
B
32.4/40.8
R411
R412
R413
R414
R415
R421
R422
R431
R432
R433
R434
R435
R441
R442
R443
R451
R452
R453
R454
R461
R462
R463
R464
R465
R466
R467
R468
R470
R471
R472
R473
R474
R475
R476
R477
R478
R481
R482
R491
R492
R493
R494
R495
R496
R497
R498
R501
R502
R503
R504
R511
R512
R513
R521
R531
R532
R533
R534
R535
R536
R537
R538
R539
R540
R551
R552
7030003560
7030003560
7030003620
7030003820
7030003820
7030003260
7030003200
7030003610
7030003800
7030003480
7030003480
7030003500
7030003760
7030003760
7030003680
7030003280
7030003440
7410000950
7030003560
7030003620
7030003520
7030003480
7030003580
7030003690
7030003560
7030003400
7030003680
7030003680
7030003640
7030003590
7030003520
7030003520
7030010290
7030004740
7030004730
7030003520
7030003680
7030003680
7030003580
7030003720
7030003770
7030003680
7030003520
7030003720
7030003710
7030003680
7030003680
7030003620
7030003690
7030003560
7030003610
7030003700
7030003590
7030003420
7030003600
7030003600
7030003650
7030003710
7030003560
7030003640
7030003640
7030003440
7030003640
7030003580
7030003560
7030003480
T
T
T
T
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
62.9/42.5
60/40.2
56.5/40.3
54.3/43.1
6.4/17.6
19.7/44.7
30.7/40.6
16.5/42.1
16.5/43.4
3.5/43.5
6.7/46.3
3.9/46.2
49.5/30.7
51.9/26.6
57.4/28.7
51.9/16.4
55.4/14.2
61.9/10.4
55.3/17.5
54.5/9.8
44.6/9.8
41/9.8
60.9/11
59/10.4
57.7/10.4
53.5/14.4
55.7/15.7
52/10.9
41/7
36.7/8.9
39.7/7
37.6/7.2
36.4/10.2
30.9/7.8
35.6/6.7
52.2/14.2
28.6/6.2
24.7/5.3
14.9/4.3
13.4/8.5
11.1/5.9
11.8/3.9
13.1/5.6
9.8/10
16.8/11.6
16.1/8.8
10.6/7.8
8.2/9.5
6.9/9.5
4.9/8.7
12.9/10.4
11.1/10
14.2/14.4
4.9/10.2
10/16
9/12.5
8.5/13.8
8.4/16.2
17.1/5.8
19.1/5.2
19.1/6.5
23.2/13.6
19.9/8.5
20.1/11.3
18.1/26.3
14.4/20.2
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARY
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
US=USA, US1=USA−1
6-1
H/V
M. LOCATION
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 155 V (1.5 MΩ)
ERJ3GEYJ 330 V (33 Ω)
ERJ3GEYJ 105 V (1 MΩ)
ERJ3GEYJ 222 V (2.2 kΩ)
EXB-V8V 102JV
ERJ3GEYF 273 V (27 kΩ)
ERJ3GEYF 392 V (3.9 kΩ)
S.=Surface mount
[LOGIC UNIT]
REF
NO.
[LOGIC UNIT]
ORDER
NO.
DESCRIPTION
REF
NO.
H/V
M. LOCATION
R553
R561
R562
R571
R572
R581
R582
R583
R591
R592
R601
R602
R603
R604
R605
R606
R611
R612
R621
R631
R632
R633
R651
R652
R653
R654
R681
R682
R683
R684
7030003600
7030003560
7030003520
7030005930
7030008090
7030003560
7030003440
7410000750
7030003560
7030003560
7030003200
7030003800
7030003570
7030003570
7030003570
7030003440
7030003560
7030003520
7030003760
7410000800
7030003680
7410000800
7030003380
7030003360
7030003440
7030003420
7030003790
7030003730
7030003750
7030003830
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARY
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARY
S.RES
S.ARY
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ3EKF 1503 V (150 kΩ)
EXB-V4V 104JV (100 kΩ)
B
B
B
B
B
B
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
12.4/19.4
20.1/16.1
22.3/20.1
19.7/33.1
22.3/33
46.8/38.8
54.5/20.2
53.3/22.3
46.6/40.5
46.6/43.2
42.4/34
43.7/34
44.8/38.1
45/34.1
48.9/33.7
47.5/29.9
4.4/17.3
6.4/15.9
39.7/9.8
12.2/33.1
12.2/26.6
12.2/29.1
27.6/14.2
26.3/14.2
24.5/17.9
24.5/16.6
43.3/16.4
42.7/15.1
45.9/15.1
48.2/16
C411
C412
C413
C421
C422
C423
C424
C425
C426
C427
C431
C432
C441
C451
C452
C453
C454
C455
C456
C457
C461
C462
C463
C464
C465
C466
C467
C471
C472
C473
C481
C491
C492
C502
C503
C504
C511
C512
C521
C522
C531
C532
C533
C534
C535
C536
C551
C552
C553
C554
C555
C556
C557
C561
C571
C581
C582
C591
C601
4030017480
4550006140
4030011600
4550006210
4030011600
4030006860
4550006700
4030007090
4030008920
4550007050
4030017490
4030011600
4030007090
4030006860
4030006860
4030011600
4030007090
4030011600
4030011600
4030007090
4030006860
4030011600
4030006900
4030011600
4030006900
4030011600
4550006700
4030006900
4550006950
4030006900
4030006900
4030006900
4030017490
4030007150
4030006880
4030009980
4030008650
4030011600
4030011600
4030008880
4030008920
4030008910
4030011600
4030009490
4030006900
4030008920
4550006710
4030006860
4550006820
4030006900
4030011810
4030006860
4550006710
4030006900
4030006900
4030008890
4030007090
4030006900
4030007050
S.CER
S.TAN
S.CER
S.TAN
S.CER
S.CER
S.TAN
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.TAN
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1608 JB 1A 474K-T
ECST1EY474R
C1608 JB 1E 104K-T
ECST1CX106R
C1608 JB 1E 104K-T
C1608 JB 1H 102K-T
ECST1AY106R
C1608 CH 1H 470J-T
C1608 JB 1H 473K-T
ECST1AD157R
C1608 JB 1A 105K-T
C1608 JB 1E 104K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 CH 1H 470J-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1E 104K-T
ECST1AY106R
C1608 JB 1H 103K-T
ECST0JX476R
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1A 105K-T
C1608 CH 1H 151J-T
C1608 JB 1H 472K-T
C1608 JB 1H 152K-T
C1608 JB 1H 332K-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1H 223K-T
C1608 JB 1H 473K-T
C1608 JB 1H 393K-T
C1608 JB 1E 104K-T
C1608 JB 1H 821K-T
C1608 JB 1H 103K-T
C1608 JB 1H 473K-T
ECST1AX226R
C1608 JB 1H 102K-T
ECST1DX106R
C1608 JB 1H 103K-T
C1608 JB 1A 224K-T
C1608 JB 1H 102K-T
ECST1AX226R
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 273K-T
C1608 CH 1H 470J-T
C1608 JB 1H 103K-T
C1608 CH 1H 220J-T
T
T
T
B
B
B
B
B
B
B
B
B
T
T
B
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
65.7/42.5
67.2/44.7
61.7/43.9
19.4/37.5
18.5/42.6
19.8/42.6
17.7/46.5
30/43.4
29.4/41.2
26.8/36.4
16.5/44.7
3.9/44.8
53.2/25.3
50.6/16.4
67.8/10.4
55.6/10.3
54.3/11.3
57.5/15.8
65.5/13.6
59.4/12.9
54.5/11.1
46.6/10.4
42.6/9.7
62.9/10.4
56.4/10.4
56.8/17
60.2/14.8
47.8/4.4
33.3/7.2
45/4.4
24.8/11
2.9/7.4
15.5/11.6
7.7/7.5
13.4/7.2
11.9/13.8
14.2/11.6
12.2/12.3
4.9/7.4
2.7/11.8
18.1/11.6
21.9/5.2
21.9/6.5
21.2/8.5
24.6/12.3
16/14.4
21.3/24.7
11.8/36.6
16.1/38
12.2/42.1
12.4/21.5
13.2/36.6
22/29.4
20.6/18.2
21/33
54.5/42
52.9/18.9
48.6/43.2
41.8/38.8
ORDER
NO.
C602
C603
C604
C605
C606
C611
C612
C621
C622
C623
C641
C642
C643
C661
C662
C663
C664
C665
C666
C667
C668
C669
C670
C671
C681
C682
C683
C684
C685
4030006980
4030007070
4030006900
4030007090
4030006900
4030006860
4030008880
4030006860
4030006860
4030006860
4550006710
4030006900
4030006900
4030008920
4030008920
4030008920
4030008920
4030008920
4030008900
4030008920
4030008920
4030008920
4030008920
4030011600
4030011600
4030017480
4030017480
4030017480
4030017480
J401
J411
H/V
M. LOCATION
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
42.8/37.5
44.1/36.1
47/34.5
47/33.2
47/31.9
2.6/20.3
2.6/17.6
33.3/44
1.6/32.1
37.6/5.9
16.1/17.8
25.6/30
28.1/32.6
48.9/31.1
50.2/31.1
48.5/28.2
49.2/26.2
52.9/22.3
51/22.2
52.9/21
49.5/20.1
51.3/17.8
50/17.8
53.2/18.6
38.4/11.2
47.5/17.9
44.6/17.7
46.1/16.4
45.7/19.2
6510023520 S.CNR 54104-3692
6510018350 S.CNR S3B-ZR-SM3A-TF
B
B
5.8/30.8
65.5/37.9
DS651
DS652
DS653
DS654
DS681
5040002660
5040002660
5040002310
5040002310
5030002770
T
T
T
T
47.8/32.7
47.8/16.7
11.2/32.8
11.2/16.6
MC461
7700002630 MIC
SKB-2246T-C33
S461
S641
2230001060 S.SW
2230001060 S.SW
EVQ-PUL 02K
EVQ-PUL 02K
B
B
67.6/44.8
51.4/44.8
W522
W523
W581
W641
7030003860
7030003860
7030003860
7030003860
S.RES
S.RES
S.RES
S.RES
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
B
B
B
[US1] only B
5.2/12.3
2.7/14.6
40.7/36.3
34.8/39.9
EP401
EP451
EP452
EP454
EP458
EP459
EP681
0910055613
6910012350
6910012350
6910012350
6910012350
6910012350
8930059150
PCB
S.BEA
S.BEA
S.BEA
S.BEA
S.BEA
LCT
B 5891C
MMZ1608Y 102BT
MMZ1608Y 102BT
MMZ1608Y 102BT
MMZ1608Y 102BT
MMZ1608Y 102BT
SRCN-2600-SP-N-W
T
T
B
T
T
67.8/10.3
65.9/10.3
64.7/10.4
58.3/10.3
57/10.3
S.LED
S.LED
S.LED
S.LED
LCD
C1608 CH 1H 070D-T
C1608 CH 1H 330J-T
C1608 JB 1H 103K-T
C1608 CH 1H 470J-T
C1608 JB 1H 103K-T
C1608 JB 1H 102K-T
C1608 JB 1H 223K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
ECST1AX226R
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 333K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1H 473K-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
FY1101F-TR (LED)
FY1101F-TR (LED)
SML-311YTT86
SML-311YTT86
L2-0390TAY-1
[CHASIS UNIT]
REF
NO.
ORDER
NO.
J41
6910014700 CNR
2600 ANT CONNECTOR
SP1
2510001092 SP
036D0801B <FG>
W1
W2
W41
7120000470 JMP
7120000470 JMP
8900011880 CBL
ERDS2T0
ERDS2T0
OPC-1210 (P=0.5 N=36 L=70)
US=USA, US1=USA−1
6-2
DESCRIPTION
H/V
M. LOCATION
S.=Surface mount
[MAIN UNIT]
REF
NO.
[MAIN UNIT]
ORDER
NO.
DESCRIPTION
IC1
IC141
IC231
IC251
IC261
IC281
IC282
IC311
IC331
IC341
IC381
IC382
IC383
1140005990
1110002750
1110003200
1190000350
1110003800
1130007300
1130006220
1120002830
1190001860
1130007570
1110004990
1110003800
1130007990
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
MB15A02PFV1-G-BND-ER
TA75S01F (TE85R)
TA31136FN (EL)
M62363FP-650C
NJM2904V-TE1
TC4W66FU (TE12L)
TC4W53FU (TE12L)
NJM2125F-TE1
EW-460-FT
BU4094BCFV-E2
FX214LG/TR
[US1] only
NJM2904V-TE1
TC3W03FU (TE12L)
B
B
B
B
T
T
T
B
B
B
B
B
T
34/35
72.8/22.6
17.6/11.3
6.3/22.6
18.4/27.1
16.2/19.7
25.2/21.3
24.6/20.2
50.7/39.9
15.8/22.1
18.3/34.6
7.7/35.2
17.1/35.9
Q1
Q2
Q3
Q41
Q47
Q51
Q61
Q62
Q71
Q81
Q82
Q91
Q101
Q111
Q141
Q165
Q171
Q191
Q211
Q221
Q231
Q232
Q291
Q321
Q322
Q323
Q381
1560000840
1530002600
1560000540
1530002920
1590001190
1530002920
1530002380
1530002380
1530002380
1590001400
1590000430
1530003420
1560001240
1560001230
1590000720
1580000750
1560000840
1580000760
1530002600
1530002690
1590000720
1530003310
1590001650
1510000670
1510000670
1510000670
1590000430
S.FET
S.TR
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.FET
S.FET
S.TR
S.FET
S.FET
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
2SK1829 (TE85R)
2SC4215-O (TE85R)
2SK880-Y (TE85R)
2SC4226-T1 R25
XP6501-(TX) .AB
2SC4226-T1 R25
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
XP1214 (TX)
DTC144EUA T106
2SC5110-O (TE85R)
RD01MUS1]
RD07MVS1
DTA144EUA T106
3SK294 (TE85L)
2SK1829 (TE85R)
3SK299-T1 U73
2SC4215-O (TE85R)
2SC4116-GR (TE85R)
DTA144EUA T106
2SC5107-O (TE85R)
XP4601 (TX)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
DTC144EUA T106
T
T
T
T
T
T
T
T
T
B
B
B
T
T
B
T
T
T
B
B
B
B
T
T
T
T
T
29.6/35.5
38.1/39.3
29.2/31.7
49.2/32.5
45.8/37.8
49.1/26.6
50.3/22.3
47.5/17.3
36.2/17.5
43.5/24.3
40.4/22.6
49.2/26.7
60.2/28
59.8/21.9
72.6/19
50.1/5.9
50.7/13.5
35.9/4.5
20.4/4.2
34.4/21.7
10.9/16.7
18.1/15.8
29.5/23.7
49.7/36.5
54.1/39.4
58/38.1
25.1/34.8
D1
D2
D3
D31
D32
D33
D34
D35
D36
D37
D38
D39
D91
D92
D121
D131
D132
D141
D151
D152
D153
D154
D155
D171
D181
D182
D231
D232
1790001250
1750000830
1790001250
1750000710
1750000710
1750000710
1750000710
1750000710
1750000710
1750000710
1750000710
1720000400
1790000620
1790000620
1790001670
1750000580
1790001210
1790001240
1750000580
1790000620
1750000580
1720000780
1720000780
1790001250
1720000780
1720000780
1750000520
1750000520
S.DIO
S.VCP
S.DIO
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.VCP
S.VCP
S.DIO
S.VCP
S.VCP
S.DIO
S.DIO
MA2S111-(TX)
HVC362TRF
MA2S111-(TX)
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
HVC350BTRF
1SV245 (TPH3)
MA77 (TX)
MA77 (TX)
RB706F-40T106
1SV307 (TPH3)
1SS375-TL
MA2S728-(TX)
1SV307 (TPH3)
MA77 (TX)
1SV307 (TPH3)
HVU350B TRF
HVU350B TRF
MA2S111-(TX)
HVU350B TRF
HVU350B TRF
DAN222TL
DAN222TL
B
T
T
T
T
T
T
T
T
T
T
B
B
B
B
T
B
B
T
T
B
B
B
T
T
T
B
B
34.2/31.5
32.6/37.5
35.8/40.9
39.9/32.7
40/30.7
37.9/33.4
40/29.4
39.1/27.4
40.5/27.4
39.8/25.4
39.8/24.1
40.1/18.6
50.3/16.1
52/12.6
67.1/15.5
63.8/5.6
68.7/3.9
69.3/14.2
63.9/2.8
57.8/2.8
62.9/8.8
61.6/4.1
54.6/6.3
54.5/7.9
44.2/6.8
40.7/6.1
4.6/9.1
8.1/10.9
FI211
FI231
FI232
2030000210 S.MLH FL-353 (31.05 MHz)
2020001270 CER
CFWLB450KE2A-B0
2020001410 CER
CFWLB450KGFA-B0
B
29.8/6.9
X1
X231
X381
6050011070 S.XTL CR-664A (15.300 MHz)
6070000190 S.DCR CDBCB450KCAY24-R0
6050011560 S.XTL CR-746 (4.000 MHz)
B
T
[US1] only T
34/40
21.1/5.6
19.4/40.3
L31
L32
L33
L34
L35
L41
L47
6200005540
6200009460
6200005540
6200008390
6200008380
6200008190
6200002610
B
T
B
T
B
T
B
42.2/31.6
37.1/31.2
42.4/28
37/26.5
38/28.9
42.7/29.5
49.1/36
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
ELJNC R47K-F
0.25-1.9-7TL 67N
ELJNC R47K-F
0.25-1.9-9TL
0.28-1.0-11TR 42N
0.25-1.9-8TL 80N
NL 252018T-R47J
REF
NO.
H/V
M. LOCATION
ORDER
NO.
DESCRIPTION
H/V
LOCATION
L51
L61
L62
L71
L72
L81
L82
L92
L102
L112
L121
L122
L123
L124
L131
L132
L151
L152
L153
L154
L155
L156
L165
L166
L181
L191
L203
L221
L222
6200008390
6200006980
6200006980
6200006980
6200005720
6200007170
6200007170
6200005710
6200007690
6200008260
6200008510
6200008230
6200008280
6200003090
6200009800
6200008580
6200008280
6200008280
6200003960
6200007750
6200007750
6200002150
6200003960
6200007750
6200007750
6200005540
6200009180
6200001980
6200001980
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
S.COL
0.25-1.9-9TL
ELJRE R10G-F
ELJRE R10G-F
ELJRE R10G-F
ELJRE 33NG-F
MLF1608A 3R3K-T
MLF1608A 3R3K-T
ELJRE 27NG-F
LQW2BHN18NJ01L
0.30-1.7-8TL 60N
0.30-0.9-4TR 10.5N
0.30-1.3-5TL 22N
0.30-1.7-7TL 50N
NL 322522T-2R7J-3
0.26-1.1-7TR 30N
0.30-1.4-6TL 32N
0.30-1.7-7TL 50N
0.30-1.7-7TL 50N
MLF1608A 1R0K-T
LQW2BHN56NJ01L
LQW2BHN56NJ01L
ELJNC 56NK-F
MLF1608A 1R0K-T
LQW2BHN56NJ01L
LQW2BHN56NJ01L
ELJNC R47K-F
ELJRE R10J-F3
NL 252018T-1R0J
NL 252018T-1R0J
T
T
T
T
T
B
B
B
T
T
T
T
T
T
T
T
T
T
B
B
B
T
T
T
T
T
B
B
B
44.1/24.7
48.1/20.6
46.1/19.4
38.1/17.7
36.5/21
47/26.9
47.2/20.9
50.5/29
67.2/27.8
65.7/21.1
55.9/18.1
56.9/12.7
57.7/8
62.6/11
66.9/9.7
67.6/14.3
67.2/3.6
60.2/3
62.8/11.2
58.4/3.4
52.2/4.1
54.9/5.4
46.5/11.5
47.8/9
41.4/3.4
34.7/8.5
41.2/4.5
31.5/20
26.1/14.9
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R19
R20
R21
R22
R31
R32
R33
R34
R35
R36
R37
R38
R39
R41
R42
R43
R47
R51
R52
R53
R61
R62
R63
R64
R65
R71
R72
R81
R82
R83
R91
R92
R93
R94
R95
R96
R97
R98
R101
R102
R103
R111
7030003700
7030003240
7410000950
7510001660
7030003940
7030003560
7030003610
7030003690
7030003560
7030003760
7030003640
7030003280
7030003670
7030003640
7030003450
7030003290
7030003320
7030003440
7030003400
7030003440
7030003560
7030003550
7030003200
7030003440
7030003440
7030003200
7030003710
7030003640
7030003680
7030003640
7030003680
7030003460
7030006571
7030004040
7030003480
7030003490
7030005331
7030004040
7030003320
7030003660
7030004040
7030003640
7030003320
7030003660
7030003360
7030003380
7030003390
7030003560
7030003440
7030003320
7030003560
7030003460
7030003400
7030003500
7030003200
7030003320
7030003520
7030003620
7030003300
7030003200
S.RES
S.RES
S.ARY
S.TMR
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
EXB-V8V 102JV
NTCG16 4LH 473KT
ERA3YED 392V
ERJ3GEYJ 4R7 V (4.7 Ω)
ERA3YED 562V
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
B
B
B
B
T
T
T
B
T
T
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
28.4/28.8
31.5/30.4
28.6/33.3
29.9/39.3
29.9/42
29.9/37.6
33.1/35.4
31.8/35.4
29.3/40.9
29.6/33.6
30.1/38.9
40.3/39.2
38/41.3
34.4/40.9
39.7/37.3
35.8/28.9
39.2/34.6
43.5/34.5
44.9/34.5
31.8/29.7
31.3/31.7
2.7/30.4
44.6/31.8
42.9/32.7
36.9/29
46/31.9
37.4/20.1
37.7/17.5
37.4/18.8
36.3/14.7
40.4/16.2
47.3/32.7
45.4/33.2
48.2/29.6
45.8/35.9
46.3/28
46/29.3
46.6/26.7
49.7/19.1
52.2/22
45.5/21.4
45.3/17.4
43.3/18.4
40.5/19.8
40.5/18.1
45.7/25.7
45.2/21.9
38.2/22.1
52.9/15
50.1/22.1
50.1/19.3
53.4/22.9
52.5/27
51.9/29.3
51.1/32.1
47.7/24.5
67.3/31.6
66.9/27.7
65.5/31.7
65.5/24.7
US=USA, US1=USA−1
6-3
M.
S.=Surface mount
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
R112
R113
R114
R121
R122
R131
R132
R133
R141
R142
R143
R144
R145
R146
R147
R148
R149
R151
R152
R153
R154
R155
R156
R165
R166
R167
R171
R172
R173
R175
R181
R182
R183
R184
R185
R186
R191
R192
R193
R201
R202
R203
R204
R205
R206
R211
R213
R214
R215
R216
R221
R222
R223
R231
R232
R233
R234
R235
R236
R237
R238
R239
R240
R241
R242
R243
R244
R245
R246
R251
R261
R262
R263
R264
R265
R266
R267
R269
R270
R271
R272
R273
R274
R275
R276
R277
R278
R279
R280
R281
R283
R284
ORDER
NO.
7030003200
7030003520
7030003680
7030003580
7030000280
7030003670
7030003560
7030003580
7030003700
7030003630
7030003480
7030003490
7030003570
7030003560
7030003700
7030003320
7030003440
7030003320
7030003600
7030003720
7030003560
7030003720
7030003560
7030003680
7030003730
7030003400
7030003560
7030003760
7030003530
7030003560
7030003430
7030003720
7030003560
7030003720
7030003560
7030003520
7030003330
7030003320
7030003500
7030003440
7030003560
7030003400
7030003210
7030003400
7030003520
7030003440
7030003460
7030003400
7030003690
7030003420
7030003780
7030003450
7030003340
7030003500
7030003280
7030003580
7030003600
7030003600
7030004040
7030003570
7030003580
7030003720
7030003640
7030003540
7030003390
7030004040
7030003480
7030003640
7030003640
7030003400
7030003520
7030003570
7030003640
7030003550
7030003560
7030003530
7030003560
7030003680
7030003580
7030003650
7030003700
7030003440
7030003480
7030003710
7030003560
7030003750
7030010290
7030004910
7030004730
7030003680
7030003680
7030003680
DESCRIPTION
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
MCR10EZHJ 150 Ω (151)
ERJ3GEYJ 472 V (4.7 kΩ) [US1] only
ERJ3GEYJ 222 V (2.2 kΩ) [US1] only
H/V
M.
LOCATION
T
B
B
B
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
B
B
B
B
B
B
T
T
T
T
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
REF
NO.
66.9/24.7
68.4/24.8
66.9/23.5
67/13.3
65.3/17.5
70.1/12.9
66.8/5
67.8/7.4
69.1/16.9
72.4/17.1
70.4/19.7
69.1/19.7
66.5/21.5
67.8/21.1
70.4/22.6
71.2/25.1
69.6/29
60.8/9.9
59.6/11.2
63.5/6
65.8/7.8
54.2/9.4
55.7/9.4
51.8/7.9
51.5/3.1
47.6/3.1
47.7/14.1
53/9.9
52.9/13.4
49.8/9.4
46.5/5.1
43.7/8.4
43.7/9.7
40.7/7.8
40.7/9.1
36.1/2.6
31.2/5.9
35.3/11.1
32.6/5.9
49.5/11.8
51.4/10.2
49.2/6.9
48.6/8.9
47.5/6.9
38.6/5.1
35.9/8.5
23.3/4.3
22.8/8.9
22.9/5.6
21.8/6.9
32.2/23.1
32.9/19.6
15.5/9.6
22.1/10.2
25/9.2
3.4/6.4
7/9
8.5/13.5
4.9/11
4.7/15.7
11.1/13.4
14.3/14
9.8/13.1
10.7/11.1
17.5/13.6
9.8/10.9
20.7/14.9
14.1/15.8
14.2/17.3
12.7/27.2
24.9/26
22.6/25.3
25.8/29.9
24.6/28.6
22.6/28.1
21.3/28.1
24.6/27.3
13.1/26.6
22.2/30.4
24.9/31.2
22.2/31.7
18.5/32.5
17.2/32.5
15.6/24.9
13.1/21.4
13.4/18.6
42.4/38.5
42.4/37.2
42.4/39.8
18.7/16.9
22.1/22
22/16.8
ORDER
NO.
M.
H/V
LOCATION
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
T
T
T
T
T
T
B
B
B
B
B
B
B
T
T
T
25.4/15
28.2/17.6
27.6/21
30.9/18.8
31.5/20.8
31.4/23.7
28.6/27.2
30.2/20.8
32.7/23.7
28.6/25.9
27.4/25.6
28.9/23
26.2/24
23.5/23
27/19.8
26.2/22.7
21.5/22.6
51.4/39.5
42.4/35.9
54/41.6
52.9/37.1
58/40.3
55.1/36.6
46.4/39.9
6.5/41.3
7.1/39.8
4.3/35.3
8.4/28
8.4/29.3
4.7/32
20.4/35.1
23.2/35
25.8/37.7
B
B
B
B
B
T
T
T
T
T
T
T
T
B
B
B
T
T
T
T
T
T
B
B
B
B
[US1] only T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
28.6/30.8
30.4/26.7
30.4/28
26.4/27.6
28.6/42
27.5/38.6
30.6/40.9
32.3/39.6
32.5/41.6
40.8/41.3
35.2/38.4
37.8/36.7
35.8/37.1
35.2/26.9
41.7/35.7
46.7/35.9
31.7/28.4
32.6/32.6
2.7/27.6
41.6/32.7
42.9/27
41.6/24.9
37.7/16.2
39.1/14.7
34.6/16
42.2/19.8
45.4/31.9
45.7/30.6
49.7/29.6
51.8/31.6
51.8/32.9
51.7/30.3
45.1/41.5
48.8/40.6
52.1/37.2
38.5/20.8
40.5/22.1
46.7/24.7
48.7/24.4
51.7/29
51.7/27.6
51.4/25.5
51.7/18.4
46.8/21.4
43.3/17.1
43.3/19.7
50.4/17.1
42.9/21
40.5/16.8
36.5/19.7
37.6/23.3
35.8/23.2
45/27.7
46.5/18.9
42.6/21.7
52.9/16.3
53.4/20
51.1/34.9
49.8/31.7
48.5/31.7
47.7/23.2
53.4/34.1
68.4/30.3
R291
R292
R293
R294
R296
R297
R298
R305
R306
R307
R311
R312
R313
R314
R315
R316
R317
R321
R322
R323
R324
R325
R326
R336
R381
R382
R383
R384
R385
R386
R387
R388
R389
7030003660
7030003660
7030003660
7030003560
7030003580
7030003560
7030003520
7030003680
7030003660
7030003450
7030003680
7030003680
7030003630
7030003670
7030003750
7030003710
7030003460
7030003560
7030003520
7030003560
7030003520
7030003560
7030003520
7030003680
7030003560
7030003650
7030003680
7030003590
7030003500
7030003680
7030003800
7030003440
7030003560
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C16
C17
C19
C20
C21
C31
C32
C33
C34
C35
C36
C37
C41
C42
C43
C44
C45
C46
C47
C48
C49
C51
C52
C53
C54
C55
C56
C57
C61
C62
C63
C64
C65
C71
C72
C73
C74
C75
C81
C82
C83
C91
C92
C96
C97
C98
C99
C103
C104
4030011600
4030011600
4030006860
4030007090
4030011600
4550006560
4030006900
4030007130
4030007000
4030011600
4030007130
4030007130
4030007090
4030006860
4550006300
4550006160
4030006860
4030006860
4030006860
4030009990
4030007000
4030007080
4030006860
4030011340
4030017490
4030009540
4030009920
4030007090
4030007020
4030011340
4030006900
4030009560
4550006700
4550006700
4030007050
4030009560
4030011770
4030007050
4030007040
4030011340
4030006900
4030009500
4030006860
4030006980
4030006860
4030011600
4030007040
4030009520
4030006860
4030007020
4030007100
4030007100
4030007020
4030007020
4030007090
4030007000
4030006860
4030006860
4030007090
4030006860
4030006860
4030007130
4030011600
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1H 102K-T
C1608 CH 1H 470J-T
C1608 JB 1E 104K-T
ECST1CY225R
C1608 JB 1H 103K-T
C1608 CH 1H 101J-T
C1608 CH 1H 090D-T
C1608 JB 1E 104K-T
C1608 CH 1H 101J-T
C1608 CH 1H 101J-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
ECST1AY475R
ECST1CY155R
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 200J-T
C1608 CH 1H 090D-T
C1608 CH 1H 390J-T
C1608 JB 1H 102K-T
C1608 CH 1H 471J-T
C1608 JB 1A 105K-T
C1608 CH 1H 1R5B-T
C1608 CH 1H 050B-T
C1608 CH 1H 470J-T
C1608 CH 1H 120J-T
C1608 CH 1H 471J-T
C1608 JB 1H 103K-T
C1608 CH 1H R75B-T
ECST1AY106R
ECST1AY106R
C1608 CH 1H 220J-T
C1608 CH 1H R75B-T
C1608 CH 1H 060B-T
C1608 CH 1H 220J-T
C1608 CH 1H 180J-T
C1608 CH 1H 471J-T
C1608 JB 1H 103K-T
C1608 CH 1H 0R5B-T
C1608 JB 1H 102K-T
C1608 CH 1H 070D-T
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 CH 1H 180J-T
C1608 CH 1H 020B-T
C1608 JB 1H 102K-T
C1608 CH 1H 120J-T
C1608 CH 1H 560J-T
C1608 CH 1H 560J-T
C1608 CH 1H 120J-T
C1608 CH 1H 120J-T
C1608 CH 1H 470J-T
C1608 CH 1H 090D-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 101J-T
C1608 JB 1E 104K-T
US=USA, US1=USA−1
6-4
DESCRIPTION
S.=Surface mount
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
C105
C106
C107
C111
C112
C113
C114
C115
C121
C122
C123
C124
C125
C126
C127
C128
C129
C131
C132
C133
C134
C135
C136
C137
C138
C141
C142
C143
C144
C145
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
C171
C172
C173
C181
C182
C183
C184
C185
C186
C187
C188
C189
C191
C192
C193
C194
C195
C201
C202
C203
C210
C211
C213
C215
C216
C217
C221
C222
C223
C224
C225
C226
C231
C232
C233
C234
C235
C236
C237
C238
C239
C240
C241
C242
C243
C244
C245
C246
ORDER
NO.
4030006860
4030006860
4030007050
4030007130
4030006860
4030011600
4030007090
4030006860
4030007100
4030006990
4030007030
4030006860
4030007030
4030007040
4030006860
4030007090
4030006860
4030006860
4030007050
4030011530
4030009650
4030006980
4030007000
4030006860
4030009510
4030011600
4030006860
4030011600
4030006900
4030006860
4030007000
4030007010
4030009530
4030006860
4030006860
4030011770
4030007060
4030006860
4030009550
4030009510
4030007100
4030006860
4030009910
4030006980
4030006900
4030007090
4030006900
4030011770
4030017480
4030006860
4030007090
4030006860
4030007120
4030006860
4030009550
4030009510
4030007070
4030006860
4030011770
4030009920
4030006860
4030007090
4030007100
4030008880
4030006860
4030006860
4030007060
4030006990
4550006300
4030006860
4030011770
4030006860
4030006900
4030007130
4030007010
4030006900
4030007040
4030009520
4030007040
4030007010
4030006860
4030007130
4030011600
4030011600
4030011600
4030006900
4030007140
4030007140
4550006300
4030006860
4030011600
4030006860
4030006860
4030006860
4030006860
4030011340
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 220J-T
C1608 CH 1H 101J-T
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 CH 1H 560J-T
C1608 CH 1H 080D-T
C1608 CH 1H 150J-T
C1608 JB 1H 102K-T
C1608 CH 1H 150J-T
C1608 CH 1H 180J-T
C1608 JB 1H 102K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 220J-T
C1608 CH 1H 110J-T
C1608 CH 1H 240J-T
C1608 CH 1H 070D-T
C1608 CH 1H 090D-T
C1608 JB 1H 102K-T
C1608 CH 1H 010B-T
C1608 JB 1E 104K-T
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 JB 1H 102K-T
C1608 CH 1H 090D-T
C1608 CH 1H 100D-T
C1608 CH 1H 030B-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 060B-T
C1608 CH 1H 270J-T
C1608 JB 1H 102K-T
C1608 CH 1H 2R5B-T
C1608 CH 1H 010B-T
C1608 CH 1H 560J-T
C1608 JB 1H 102K-T
C1608 CH 1H 040B-T
C1608 CH 1H 070D-T
C1608 JB 1H 103K-T
C1608 CH 1H 470J-T
C1608 JB 1H 103K-T
C1608 CH 1H 060B-T
C1608 JB 1A 474K-T
C1608 JB 1H 102K-T
C1608 CH 1H 470J-T
C1608 JB 1H 102K-T
C1608 CH 1H 820J-T
C1608 JB 1H 102K-T
C1608 CH 1H 2R5B-T
C1608 CH 1H 010B-T
C1608 CH 1H 330J-T
C1608 JB 1H 102K-T
C1608 CH 1H 060B-T
C1608 CH 1H 050B-T
C1608 JB 1H 102K-T
C1608 CH 1H 470J-T
C1608 CH 1H 560J-T
C1608 JB 1H 223K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 270J-T
C1608 CH 1H 080D-T
ECST1AY475R
C1608 JB 1H 102K-T
C1608 CH 1H 060B-T
C1608 JB 1H 102K-T
C1608 JB 1H 103K-T
C1608 CH 1H 101J-T
C1608 CH 1H 100D-T
C1608 JB 1H 103K-T
C1608 CH 1H 180J-T
C1608 CH 1H 020B-T
C1608 CH 1H 180J-T
C1608 CH 1H 100D-T
C1608 JB 1H 102K-T
C1608 CH 1H 101J-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1H 103K-T
C1608 CH 1H 121J-T
C1608 CH 1H 121J-T
ECST1AY475R
C1608 JB 1H 102K-T
C1608 JB 1E 104K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 CH 1H 471J-T
REF
NO.
H/V
M. LOCATION
B
T
T
T
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
T
T
T
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
B
B
B
T
T
T
B
B
T
T
T
B
B
66.9/29
68.3/30.4
65.5/27.5
64.1/26.2
66.9/26.4
69.7/26.4
68.4/23.2
68.4/20.3
56.9/15.7
55/12.7
59.6/12.4
55.7/10.5
59.6/11.1
62.8/8
60.8/7.7
67.5/16.3
65.4/12.2
66.2/6.5
68.2/7.3
65/9.7
68.8/9.8
68.2/12.2
70.1/10
66.1/3
68.7/6.1
70.4/16.9
66.9/17.7
69.1/22.6
74/25.1
67.6/34
68.2/5.7
62.3/2.9
56.2/2.8
61/7.9
62.8/12.5
59.5/5.9
64/3.4
65.5/5
61.3/2.4
56.7/3.2
52.8/6.5
55.6/11.4
55.4/3.2
53.6/3.4
50.2/3.1
48.9/3.1
46.1/9
58.9/5.6
49.3/11.5
52.2/5.9
51.7/9.9
47.3/6.5
43.7/3.1
43.7/11
45.6/3.1
43.7/5.1
38.3/6.5
37.9/8.4
39.7/3.1
38.4/3.1
33.9/3.1
31.9/3.8
34.6/6.5
31.5/9.3
31.5/8
50.6/6.9
51.4/8.9
40.7/6.6
39.4/12
34.9/9.8
27.6/3.5
26.6/10.3
24.7/8.6
19.8/7.1
32.4/28.1
30.9/23.1
31.3/16.3
29.8/17.6
28.1/15.3
20.7/16.2
15.5/8.2
20.1/10.9
9.8/8.5
9.8/13.7
7.9/16
11.1/10.5
13.5/12
11.5/13.1
11.5/9.3
12.4/9.3
12.4/13.8
17.4/14.9
17.5/12.3
20.7/13.6
22.7/14.1
16.2/16.7
ORDER
NO.
C247
C251
C252
C253
C261
C262
C263
C265
C266
C267
C268
C269
C270
C271
C272
C281
C282
C291
C292
C293
C294
C301
C302
C311
C312
C313
C314
C315
C316
C322
C323
C324
C325
C326
C327
C333
C341
C381
C382
C383
C384
C385
C386
C387
C388
C389
C391
C392
C393
C394
C395
C396
C397
C398
4030006860
4030006900
4030006900
4030006900
4030008860
4030008900
4030008920
4030006860
4030007150
4030006880
4030008920
4030006900
4030017490
4550006950
4030017480
4030006900
4030006900
4030006900
4030009880
4030008900
4030009970
4030008880
4030006870
4030006860
4030008880
4030009490
4030009490
4030011600
4030008920
4030006900
4030006900
4030006900
4550006710
4550006300
4550006300
4030006860
4030006900
4030017490
4030017490
4030017490
4030011600
4030011600
4030017490
4030017490
4030006900
4030006900
4030011600
4030007060
4030007060
4030007140
4030011600
4030017490
4030017490
4030007020
J281
J351
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
T
B
B
B
[US1] only T
T
T
T
T
T
T
T
T
B
T
T
B
T
T
T
T
T
T
B
B
B
B
B
B
T
T
T
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
17.4/11
5.3/17
12.3/19.3
12.3/25.1
24.9/24.7
22.1/23.3
21.3/25.3
14.9/29.3
20.3/31.2
24.9/32.5
14.4/31.7
13.6/24.7
15.9/32.5
40.7/40.4
20/16.1
22.1/20.4
70.5/31
32.2/17
26.9/16.3
28.9/19.7
27.6/23.8
31.6/26.2
28.6/28.5
25.4/17.4
28.9/24.3
23.5/24.3
19.8/18.1
28.4/21
21.8/19.9
51.3/41.6
56/41
58/41.6
58.9/39.4
60.8/39.5
25.3/41.1
46.5/41.9
12.3/22.3
11.8/29.2
10.1/39.7
11.9/41
5/37.3
9.2/41.3
10.4/29.4
8.4/30.6
4.3/34
4.3/30
26.3/39.3
21.7/35.1
21.1/37
13/38.2
13.6/33.8
13.1/31.5
15.1/27.5
23.8/37
6510023540 CNR
B2B-PH-K-S
6510023520 S.CNR 54104-3692
T
7.4/28.1
F281
5210000830 S.FUS ERBFE3R00U
T
75.3/23.9
W40
W91
W92
W101
W102
W201
W202
7030003860
7030003860
7030003860
7030003860
7030003860
7030003860
7030003860
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
ERJ3GE JPW V
B
B
B
B
B
B
B
37.6/31.8
51.4/19.3
51.4/22.1
53.2/29.3
52.7/32.1
45.8/8.9
42.9/8.9
EP1
EP2
EP3
EP101
EP111
0910055971
6910012350
6910012350
6910013370
6910014690
PCB
S.BEA
S.BEA
S.BEA
S.BEA
B 5933A
MMZ1608Y 102BT
MMZ1608Y 102BT
BLM18BB221SN1D
MPZ1608S221A-T
B
B
T
T
28.6/39.3
28.8/37.3
69.7/23.2
71.3/20.3
US=USA, US1=USA−1
6-5
C1608 JB 1H 102K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 153K-T
C1608 JB 1H 333K-T
C1608 JB 1H 473K-T
C1608 JB 1H 102K-T
C1608 CH 1H 151J-T
C1608 JB 1H 472K-T
C1608 JB 1H 473K-T
C1608 JB 1H 103K-T
C1608 JB 1A 105K-T
ECST0JX476R
C1608 JB 1A 474K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 682K-T
C1608 JB 1H 333K-T
C1608 JB 1H 182K-T
C1608 JB 1H 223K-T
C1608 JB 1H 222K-T
C1608 JB 1H 102K-T
C1608 JB 1H 223K-T
C1608 JB 1H 821K-T
C1608 JB 1H 821K-T
C1608 JB 1E 104K-T
C1608 JB 1H 473K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
ECST1AX226R
ECST1AY475R
ECST1AY475R
C1608 JB 1H 102K-T
C1608 JB 1H 103K-T
C1608 JB 1A 105K-T
C1608 JB 1A 105K-T
C1608 JB 1A 105K-T
C1608 JB 1E 104K-T
C1608 JB 1E 104K-T
C1608 JB 1A 105K-T
C1608 JB 1A 105K-T
C1608 JB 1H 103K-T
C1608 JB 1H 103K-T
C1608 JB 1E 104K-T
C1608 CH 1H 270J-T
C1608 CH 1H 270J-T
C1608 CH 1H 121J-T
C1608 JB 1E 104K-T
C1608 JB 1A 105K-T
C1608 JB 1A 105K-T
C1608 CH 1H 120J-T
H/V
M. LOCATION
S.=Surface mount
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
[CHASSIS PARTS]
REF
NO.
ORDER
NO.
[MAIN UNIT]
DESCRIPTION
REF
NO.
QTY.
J41
6910014700
2600 ANT connector
1
W1
W2
W41
7120000470
7120000470
8900011880
Jumper ERDS2T0
Jumper ERDS2T0
Cable OPC-1210 (P=0.5 N=36 L=70)
1
1
1
MP1
MP4
MP5
MP6
MP7
MP8
MP9
MP10
MP11
MP12
MP13
MP15
MP16
MP21
MP22
MP23
MP31
MP32
MP33
MP35
MP41
MP42
MP43
MP44
MP45
MP46
MP47
MP51
MP52
MP53
MP54
MP55
MP65
MP66
MP71
MP72
8210019140
8930058380
8930058430
8930058360
8950005520
8930055890
8930055730
8930058720
8930058370
8310054270
8930058730
8930060160
8930060020
8930059360
8930055761
8930056540
8830001470
8930051500
8610011220
8810009510
8010019080
8950005512
8930055870
8810007890
8930058550
8930058561
8810009510
8830001600
8810010190
8850001880
8810010190
8810010120
8930059830
8930059800
8210017071
8810009270
2600 Front panel Ass'y
2600 PTT button
2600 PTT plate
2600 PTT holder
2403 9-PIN connector
2403 Connector sheet
2403 Connector seal
2600 9-PIN sheet
2600 6-Key
2600 Window plate
2600 Window sheet
2600 PTT tape
2600 Tape
2600 Release button
2403 Release plate-1
Spring (AH)
VR nut (N)
O ring (AB)
Knob N294
Screw PH BT M2 × 4 NI-ZU
2600 Chassis
2403 Contact spring-2
Seal O ring (AO)
Screw PH B0 M2 × 4 SUS
Seal O ring (AS)
Seal 2403 A-main seal-1
Screw PH BT M2 × 4 NI-ZU
Nut (L)
Bind M2 × 4 black SUS
Sealing washer (W)
Bind M2 × 4 black SUS
Screw PH B0 M2 × 8 SUS ZK
2600 Sheet
2600 Pet sheet
2337 C-panel-1
Screw Truss M3 × 4 SUS ZK
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
3
1
1
1
1
1
1
6
1
2
2
1
2
1
1
1
1
SP1
2510001092
Speaker 036D0801B <KS>
1
MP41
MP42
MP101
MP111
MP151
ORDER
NO.
8510013000
8510015430
8510015250
8410002530
8510014860
QTY.
DESCRIPTION
2336
1922
2600
2681
2600
VCO case Y534
VCO cover (A)-1
Shield case
PA heat sink
Shield plate
1
1
1
1
1
[VR UNIT]
REF
NO.
ORDER
NO.
QTY.
DESCRIPTION
R801
7210003130
TD76N-13F-10KA-2497
1
W801
W802
8900011900
8900011910
OPC-1192
OPC-1193
1
1
Screw abbreviations
B0, BT: Self-tapping PH: Pan head
NI-ZU: Nickel-Zinc
ZK: Black
[ACCESSORIES]
REF
NO.
EP1
EP2
ORDER
NO.
EP4
Optional products
Optional products
Optional products
Optional products
Optional products
Optional products
Antenna
AC adaptor
AC adaptor
Battery
Battery
Charger
MP1
MP2
Optional products
Optional products
Hand strap
HK-009
Swivel belt clip MB-86
EP3
QTY.
DESCRIPTION
FA-S59V
BC-147A [USA], [USA-1]
BC-147E
[SEA]
BP-227
[USA], [SEA]
BP-227FM
[USA-1]
BC-152
1
1
1
1
1
1
1
1
[LOGIC UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
QTY.
MC461 7700002630
Microphone SKB-2246T-C33
1
MP441
MP451
MP462
MP461
MP681
MP682
MP683
6910014760
6910014760
8930059990
8930059810
8930058420
8210019110
8930059700
S. plate OG-503040
S. plate OG-503040
2600 Microphone sponge
Microphone rubber 2246
2600 LCD holder
2600 Reflector
Himelon sheet (CH)
1
1
1
1
1
1
1
DS681
5030002480
LCD L2-0390TAY
1
EP681
8930059150
LCD contact SRCN-2600-SP-N-W
1
MP2
EP4
EP3
MP1
EP2*
EP1
* Design is depended on versions.
7-1
NOTE 1
MP45 (C)
SP1 (C)
NOTE 2
J41 (C)
MP44 (C)
NOTE 1
MP32 (C)
NOTE3
MP33 (C)
NOTE 3
MP4 (C)
MP31 (C)
MP42 (C)
R801 (VR)
NOTE3
MP6 (C)
MP54 (C)
MP43 (C)
MP66 (C)
VR UNIT
W802 (VR)
NOTE 2
MP51 (C)
MP46 (C)
DS681 (L) MP682 (L)
MP65 (C)
EP681 (L)
W801 (VR)
MP683 (L)
NOTE3
MP5 (C)
MP461 (L)
MC461 (L)
MP55 (C)
MP681 (L)
MP462 (L)
MP52 (C)
MP111 (M)
MP11 (C)
NOTE 1
MP53 (C)
MP101 (M)
MP10 (C)
MP7 (C)
MP9 (C)
MP35 (C)
MP71 (C)
MP72 (C)
NOTE 3
MP13 (C)
MP42 (M)
MP151 (M)
MP43 (M)
MP52 (C)
MP12 (C)
MP41 (C)
MP47 (C)
MP8 (C)
MP21 (C)
MP53 (C)
NOTE 1
MP41 (M)
MP22(C)
MP1 (C)
MAIN UNIT
MP684 (L)
MP47 (C)
MP23 (C)
(C) : CHASSIS PARTS
W41 (C)
(L) : LOGIC UNIT
MP35 (C)
(M): MAIN UNIT
LOGIC UNIT
MP685 (L)
NOTE 1 : Once the following parts are removed, an O ring or sealing washer
must be replaced with new one before reattachement.
REF. NO.
MP45 (C)
MP53 (C)
MP32 (C)
Mother parts
NOTE 3 The glue must be applied to the
areas when the front panel is replaced with new one, to ensure water tightness.
Manufacture : Cemedine Co.
Type
: Super-X
Daughter parts for
relayted replacement
Antenna connector (J41) O ring
Sealing washer (W)
MP52 (C) Screw
O ring (AB)
R801
MP42 (C)
1 Painting from
the lower part.
1
2
MP6 (C)
MP7 (C)
2
3 Painting with the
MP5 (C)
upper part from
a crack.
MP4 (C)
A basis to
install a
speaker
NOTE 2
Apply a screw lock in the conclusion with J41 (C) and MP51 (C).
Reference No. : 89500001350
Reference Name : Screw lock 1401B
MP11 (C)
Glued
MP1 (C)
Not putting glue to the depths
of a ditch of MP1.
7-2
(VR): VR UNIT
MP11 (C)
MP1 (C)
MP41 (C)
• BC-152 CHARGER PARTS LIST
ACCESSORY PARTS
ELECTRICAL PARTS
REF
NO.
ORDER
NO.
IC1
IC2
IC3
IC4
IC5
1180000970
1190001180
1110005960
1190001470
1110002700
S.IC
S.IC
S.IC
S.IC
S.IC
AN78L05M-(E1)
MM1332BFBE
S-80833CNMC-B8S-T2
TB1009AF(EL)
NJM2904M-TE1
1
1
1
1
1
Q1
Q2
Q3
Q4
Q5
Q6
1540000550
1510000500
1590002880
1520000450
1590000700
1590000930
S.TRANSISTOR
S.TRANSISTOR
S.FET
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
2SD1664 T100Q
2SA1162-GR (TE85R)
2SJ417-TL
2SB1132 T100 Q
DTC144EKA T146
DTA144EKA T146
1
1
1
1
1
1
D1
D2
D3
D4
D5
D6
D7
1790000670
1730002540
1750000150
1730002460
1750000550
1160000070
1730002320
S.DIODE
S.ZENER
S.DIODE
S.ZENER
S.DIODE
S.DIODE
S.ZENER
SB07-03C-TB
MA8130-L(TX)
DA204K T146
MA8330-M(TX)
1SS355 TE-17
DAN202K T146
MA8051-M(TX)
1
1
1
1
1
1
1
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R19
R20
R21
R22
R23
R24
R25
R27
R28
R29
R30
7030000380
7030000140
7030000140
7030000450
7030000450
7030000500
7030002920
7030000580
7030000420
7030000260
7030000500
7030000530
7030001780
7030000500
7030000500
7030000540
7030010150
7030000530
7030000300
7030000500
7030000540
7030000550
7030000020
7030000020
7030000580
7030000500
7030000680
7030000510
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
MCR10EZHJ 1 kΩ(102)
MCR10EZHJ 10 Ω (100)
MCR10EZHJ 3.9kΩ (392)
MCR10EZHJ 10 kΩ (103)
MCR10EZHFX 39 kΩ (393)
MCR10EZHJ 100 Ω (101)
MCR10EZHFX 18 kΩ (183)
MCR10EZHF 2943 (294kΩ )
MCR10EZHJ 220 Ω (221)
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
DESCRIPTION
QTY.
REF
NO.
ORDER
NO.
W1
W2
W3
W4
7030000010
7030000010
7030000010
7030000010
QTY.
DESCRIPTION
EP1 910055642
S.JUMPER
S.JUMPER
S.JUMPER
S.JUMPER
MCR10EZHJ
MCR10EZHJ
MCR10EZHJ
MCR10EZHJ
PCB
B 5894B
JPW
JPW
JPW
JPW
(000)
(000)
(000)
(000)
1
1
1
1
REF
NO.
ORDER
NO.
MP1
8810001470
QTY.
DESCRIPTION
Screw.5 x 30 SUS
2
MP1
1
MECHANICAL PARTS
CHASSIS PARTS (C)
REF
NO.
ORDER
NO.
MP1
MP4
MP5
MP6
MP7
8010019100
8110007810
8810008660
8930039620
8930056330
DESCRIPTION
Case 2612
Cover 2612
Screw BT M3 x 8 NI-ZU
LEG cushion (A)
Summary sheet (Z) TC-100TK (7 x 7)
QTY.
1
1
3
2
1
CHARGER PARTS (CH)
REF
NO.
ORDER
NO.
MP1
MP2
MP3
MP4
8930051341
8930051341
8930051341
8930051341
DESCRIPTION
2338 TERMINAL-1
2338 TERMINAL-1
2338 TERMINAL-1
2338 TERMINAL-1
QTY.
1
1
1
1
• BC-152 VOLTAGE DIAGRAM
Q2
2SA1162
11.3V
4030004750
4510005340
4030008960
4030004720
4030004720
4510006160
4030008960
4030008960
4510006160
4030008960
4030008660
4030008960
4510006160
4030008960
4030008960
S.CERAMIC
ELECTROL
S.CERAMIC
S.CERAMIC
S.CERAMIC
ELECTROL
S.CERAMIC
S.CERAMIC
ELECTROL
S.CERAMIC
S.CERAMIC
S.CERAMIC
ELECTROL
S.CERAMIC
S.CERAMIC
C2012 JB 1H 103K-T
25 MV 47 HC
C2012 JB 1C 104K-T
C2012 JB 1H 102K-T
C2012 JB 1H 102K-T
25 MV 10 HC
C2012 JB 1C 104K-T
C2012 JB 1C 104K-T
25 MV 10 HC
C2012 JB 1C 104K-T
C2012 JB 1H 333K-T
C2012 JB 1C 104K-T
25 MV 10 HC
C2012 JB 1C 104K-T
C2012 JB 1C 104K-T
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
J1
HEC2305-01-250
D1
SB07-03C
13.7V
Q1
2SD1664
R1
1k
C1
0.01
C14
0.1
C3
0.1
6510023070
DS1 5040001390
CONNECTOR HEC2305-01-250
1
LED
1
TLG124A
Q4
2SB1132
Q3
2SJ417
7.7V
R3
10
D2
MA8130
C2
47
R6
10k
R2
10
C4
0.001
7.1V
D3
DA204K
C5
0.001
C6
1
R7
39k
7.0V
MP1
R8
47k
D4
MA8330
R9
2.2k
MP2
MP1 (CH)
MP2 (CH)
MP3 (CH)
MP4 (CH)
MP1 (C)
R10
100
IC1
AN78L05M
W2
W1
Q5
DTC144EKA
1
2
3
4
O
I
G
D5
1SS355
C7
0.1
C8
0.1
R11
10k
SW1
SW2
LV
GND
VCC
EXT
CEL
CS
8
7
6
5
R12
18k
2.3V
1
2
3
D6
DAN202K
IC2
MM1332BFBE
0V
0V
OUT
VDD
VSS
CD
NC
5
4
R13
18k
C15
0.1
5.0V
MP7 (C)
R14
10k
MP5 (CH)
MP4 (C)
IC4
TB1009AF
1
2
3
4
5
0V
CHRGEOUT
VDD
SHORTDETECT
TEST
BTDETECT
PULSESELECT
LEDOUT
COUNTERSELECT
GND
OSC
IC5
NJM2904M
10
9
8
7
6
R28
10k
R17
294k
1
2
3
4
R29
330k
R22
22k
R21
10k
8
7
6
5
MP4
C11
0.033
R15
10k
C9
1
R27
47k
C10
0.1
2.6V
R23
27k
R30
12k
R24
1
R25
1
C12
0.1
W3
MP5 (C)
MP6 (C)
W4
CHARGER UNIT
(C): CHASSIS PARTS
(CH): CHARGER PARTS
7-3
MP3
D7
MA8051
R19
18k
Q6
DTA144EKA
R16
22k
B
IC3
S-80833CNMC
R20
220
MP6 (C)
J1
DS1
TLG124A
R5
3.9k
C13
1
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
R4
3.9k
Power supply
T
SECTION 8
SEMI-CONDUCTOR
PARTS LIST
INFORMATION
8 - 1 TRANSISTORS AND FETs
• MAIN unit and LOGIC unit
2SB1132 T100 Q
(Symbol: BAQ)
2SA1588-GR
(Symbol: ZG)
E
C
E
E
2SC5107 O
(Symbol: MFO)
2SC4226-T1 R25
(Symbol: R25)
B
C
E
E
3SK294
(Symbol: UV)
3SK299-T1 U73
(Symbol: U73)
S
G1
CPH3403-TL
(Symbol: KC)
S
G2
D
G2
RD01MUS1
(Symbol: K2)
RD07MVS1
(Symbol: RD07MVS1)
D
G
S
G
DTC144EUA
(Symbol: 26)
S
A
C
A
C
A
MA8062-M(TX)
(Symbol: 6-2)
MA8056-M
(Symbol: 5-6)
C
C
A
C1
B1
B2
E2
B1
C2
E2
B2
C2
C1
E1
E
B2
B1
1SS355 TE-17
(Symbol: A)
E1
C2
B2
B
C
E
C
A
C
DA204K T146
(Symbol: K)
A1
C
MA8330-M
(Symbol: 33-)
B
G
C
D
E
S
DTC144EKA T146
(Symbol: 26)
DTA144EKA T146
(Symbol: 16)
2SJ417-TL
(Symbol: J417)
E
8-1
B
C
D
C
E
MA8130-L
(Symbol:13_ )
MA8051-M
(Symbol: 5-1)
DAN202K T146
(Symbol: N)
C2
• CHARGER unit
B
A
C1
C
A2
SB07-03C-TB
(Symbol: 12)
C
A
C
2SD1664 T100Q
(Symbol: DAQ)
C
XP1214(TX)
(Symbol: 9H)
A
2SA1162-GR
(Symbol: SG )
MA77(TX)
(Symbol: 4B)
C
C
E1
MA2S728-(TX)
(Symbol: B)
C
XP6501 AB
(Symbol: 5N)
C1
C
A
A
A
E1
A
RB706F-40T106
(Symbol: 3J)
A
XP4601(TX)
(Symbol: 5C)
C
• CHARGER unit
B1
C
S
A
MA2S111
(Symbol: A)
E
XP1213(TX)
(Symbol: 9L)
B
G
D
HVU350B TRF
(Symbol: 4)
B
C
E
UNR911FJ/HJ
(Symbol: 6O)
C
D
D
S
HVC350BTRF
(Symbol: B0)
S
B
D
DAN222TL
(Symbol: N-4)
C
HVC362TRF
(Symbol: V2)
D
DTA144EUA T106
(Symbol: 16)
G
A
C
2SK880Y
(Symbol: XY)
S
E
1SV307 (TPH3)
(Symbol: TX)
A
C
E
2SK1829(TE85R)
(Symbol: KI)
1SV245
(Symbol: T3)
A
B
G
C
C
1SS375-TL
(Symbol: FH)
C
E
2SC5110-O (TE85R)
(Symbol: MGO)
B
B
B
B
C
C
2SC4215 O/Y
(Symbol: QO/QY)
2SC4213-B
(Symbol: AB)
2SC4116 BL/GR
(Symbol: LL/LG)
B
B
G1
8 - 2 DIODES
• MAIN unit and LOGIC unit
A
C
A
C
SECTION 9
BOARD LAYOUTS
9 - 1 CHARGER UNIT (BC-152)
• BOTTOM VIEW
65
65
60
60
55
55
50
50
45
45
40
40
35
35
30
30
25
25
20
20
15
15
10
10
5
5
0
0
5
10
15
20
25
30
35
40
45
50
55
60
65
70
70
65
60
55
50
Horizontal
45
40
35
30
25
20
15
10
5
0
Horizontal
9-2 VR UNIT
9-3 CONNECTOR UNIT
• TOP VIEW
• BOTTOM VIEW
• BOTTOM VIEW
J41
VOLIN
VOLO
• TOP VIEW
J41
W801
W801
W801
GND
to LOGIC UNIT J411
9
8
10
to MAIN UNIT
J281
W802
FHV
W802
VCC
7
5
6
3
4
1
2
R801
5
Vertical
J851
9-1
CP451
AFOUT
CP452
EXTVCC
CP453
CP454
GND
CP455
CP456
CP457
CP458
to LOGIC UNIT
EDETEDT
0
ERESET
5
Horizontal
EXTRXD
10
EXTTXD
EXTPTT
CP459
1
0
EXTMIC
0
Vertical
Vertical
• TOP VIEW
9-4 MAIN UNIT
• TOP VIEW
The combination of this page and next page shows the
unit layout in the same configuration as the actual P.C.
Board.
Vertical
to VR unit
W802
35
30
FHV
VCC
VCC
VOLIN
BTYPE
S5V
M5V
V5VS
R5VS
T5VS
MICO
SMICO
W/NS
TEMPV
LOINV
CDECV
UNLKI
MODIN
CDTENC
VSSTBO
EXSTBO
DASTBO
PLSTBO
SDATAO
SCLKO
EXOEO
WDECV
RSSIV
NOISV
TDETV
BEEPO
40
VCC
to
LOGIC
UNIT
J401
CP281
J351
CP282
25
BATTERY
CP283
20
1
CP284
15
10
ANT
5
0
0
5
10
15
20
25
30
35
40
Horizontal
9-2
45
50
55
60
65
70
75
80
MAIN UNIT
The combination of this page and previous page shows
the unit layout in the same configuration as the actual
P.C. Board.
• BOTTOM VIEW
40
35
30
Vertical
25
20
15
10
5
0
80
75
70
65
60
55
50
45
40
35
30
25
20
15
Horizontal
9-3
10
5
0
9-5 LOGIC UNIT
The combination of this page and next page shows the
unit layout in the same configuration as the actual P.C.
Board.
• TOP VIEW
50
45
40
35
Vertical
30
25
20
15
10
5
0
0
5
10
15
20
25
30
35
40
Horizontal
9-4
45
50
55
60
65
70
LOGIC UNIT
• BOTTOM VIEW
70
65
60
55
50
45
40
Horizontal
35
30
25
20
15
10
5
0
50
PTT
SQL
45
1
CP442
40
SPE
SP1
CP441
AFOUT
35
J411
J401
GND
VOLO
to VR UNIT
25
20
to
MAIN
UNIT
J351
15
CP459
EXTPTT
CP458
EXTMIC
CP457
EXTTXD
CP456
EXTRXD
CP455
ERESET
CP454
GND
CP452
CP453
EDETEDT
0
EXTVCC
5
CP451
10
AFOUT
Vertical
VOLIN
30
VCC
VCC
VOLIN
BTYPE
S5V
M5V
V5VS
R5VS
T5VS
MICO
SMICO
W/NS
TEMPV
LOINV
CDECV
UNLKI
MODIN
CDTENC
VSSTBO
EXSTBO
DASTBO
PLSTBO
SDATAO
SCLKO
EXOEO
WDECV
RSSIV
NOISV
TDETV
BEEPO
+
–
MICROPHONE
MC461
to CONNECT UNIT J851
The combination of this page and previous page shows
the unit layout in the same configuration as the actual
P.C. Board.
9-5
SECTION 10
BLOCK DIAGRAM
Common
Q47: XP6501
V5V
Transmit
MAIN UNIT
Receive
RIPPLE
FIL
VCO
LVINV
Q3: 2SK880
Q1: 2SK1829
BUFF
ANTENNA
Q41: 2SC4226
D31-34:
HVC350B
BUFF
Q61: 2SC4215
Q62: 2SC4215
BUFF
BUFF
Power supply
Vcc
2
DTCON
Vcc
D39:
1SV245
X1: CR-664A
15.3 MHz
LOOP
FIL
REF
FRCON
FUSE
Q91:
2SC5110
TX/RX
SW
BUFF
Q101:
RD01MUS1
Q111:
RD07MVS1
PWR
AMP
PRE
DRIVE
146 –174 MHz
VCOS
F281
1
D91: MA77
D92: MA77
FM
MOD
IC141:
TA75S01F
Q71: 2SC4215
Q51:
2SC4226
VCO
SW
D35-38:
HVC350B
BUFF
T1CON
ATT
D132:
1SS375
PWR
DET
APC
CTRL
Q81: XP1214
Q82: DTC144EU
IC1:
MB15A02PFV
Q221:
2SC4116
R801
VOLIN
TXMS
LPF
BPF
POWER SW
X231:
CDBC450CX24
30.6 MHz
W/NS
W/N
SW
AFMS
Q211:
2SC4215
FM IF IC
IC231:
TA31136FN
DET
SQCON
MAIN UNIT
W/NS
NOISV
RSSIV
VR UNIT
FI211: FL-353
IF
AMP
Q191:
3SK299
D182:
HVU350B
D181:
HVU350B
BPF
BPF
D231:
DAN222
D232:
DAN222
W/N
SW
W/N
SW
LOGIC UNIT
EDETEDT
IC311:
NJM2125F
S5V
AFVS
CDTENC
IC421
TA7368F
AFOUT
LDTFS
WDECV
BEEP
CDECV
ISPMS
RSSIV
AFVS
NOISV
AFMS
LVINV
STXMS
TEMPV
MICMS
BATTV
PTTIN
R5V
IC281A:
TC4W66FU
IC261A:
NJM2904V
DETMS
LIMIT
INTSP
AF
MUTE
IC381:
FX214LG
IC481B:
TC4W66FU
AMP
SRXMS
IC382B:
NJM2904V
IC471A:
NJM2904V
IN/EXT
MIC SW
MIC
AMP
FIL
SW
Q561: 2SA1588
S5V
REG
S5V
LDTFS
AF
MUTE
D/A
M5V
M5V
REG
LPF
MICMS
SCRAMBLE CODE DATA BUS
COMMON LINE
CENC 1, 2, 3
LOGIC UNIT
10 -1
RX LINE
ATIS
TX LINE
IC551:
NJM2870
S5VS
CPU
5V
Q551: 2SB1132
Q552: XP6501
Q553: DTC144EU
EPTTI
CONTROL LINE
CPU
BACK
LIGHT
Q651: XP1213
DRIVER
Vcc
IC481A:
TC4W66FU
MIC
AMP
V5VS
IC661:
µPD780316GC
Q532:
2SC4116
LPF
DS651, DS652:
FY1101F
DS653, DS654:
SML-311YT
IC581: S-80942CNMC
IC591: HN58X2416TI
CPU5V
STXMS
IC471B:
NJM2904V
PREENPHA
AF
MUTE
IC382A:
NJM2904V
AMP
Q462:
UN911H
V5V
REG
RESET
Q531: XP1213
SCRAMBLE
Q461:
UN911H
LCD
CSIFT
Q321: 2SA1588
V5V
IC491B:
NJM2904V
IC281B:
TC4W66FU
D601:
MA77
SHIFT
SW
T5VS
LPF
LPF
IN/EXT
MIC SW
X601:
CR-747
9.8304 MHz
AMP
ISPMS
T5V
REG
AF
MUTE
ANALOG
SW
BEEPO
R5VS
Q323: 2SA1588
T5V
W/N
SW
IC491A:
NJM2904V
BEEPO
R5V
REG
Q501:
DTC144EU
IC282:
TC4W53FU
LPF
PTT
W/NS
TDETV
EPTTI
CTIFS
IC261B:
NJM2904V
DEENPHA
PWR
AMP
GND
PTT
CONT
BTYPE
BTYPE
Q322: 2SA1588
PWR
CTRL
EXTMIC
D451: MA8062
BTYPE
DET
D/A control BUS
MODIN
AF
MUTE
T1CON
WDETV
LPF
EXTPTT
Q441: 2SC4116
Q442: CPH3403
Q443: CPH3403
Q444:DTC144EU
T2CON
Q431: 2SB1132
Q432: XP6501
CLONE
MIC
T3CON
IC331: EW-460
D/A
Vcc
BPF
CDECV
LPF
MOCON
EXTVCC
BPF
Q291:
XP4601
IC251:
M62363FP-650C
J851
RF
AMP
BPF
D154:
HVU350B
CERAMIC
BPF
CERAMIC
BPF
Vcc
D155:
HVU350B
FI231:
CFWM450E
FI232:
CFWM450G
CONNECTOR UNIT
Q165:
3SK294
31.05 MHz
T4CON
J41
LPF
Q232: 2SC5107
Q231: DTA144EU
AF
MUTE
CHASSIS
EXP JACK
ANT
SW
MUTE
SW
PLL DATA BUS
Q411:
2SC4213
BATT
D131: 1SV307
D151: 1SV307
D152: MA77
Q141:
DTA144EU
PLL
IC
✕2
VOLO
GND
TDETV
M5VS
EEPROM
KEY
SECTION 11
VOLTAGE DIAGRAM
VCC
VCC
S5V
R2
22
R1
150k
VR UNIT VCC
FHV
to LOGIC
J411
1
2
3
W801
W801
W801
3
2
1
1
2
W802
VCC
W802
J281
1
VOLIN
VOLO
GND
S5V
S5V
R12
47
EP3
EP2
TEMPV
R801
10k-A
C5
0.1
F281
ERBFE3R00U
R5
100k
HV
CP282
HV
R4
NTCG16 4LH 473KT
FRCON
R6
10k
DTCON
Q1
2SK1829
BATTERY
CP281
C3
0.001
9
CLOCK
10
DATA
11
LE
12
FC
13
NC
14
FOUT
15
P
16
B
SDATA
C802
0.001
4
3
4.78V
C4
47p
5
2
6
1
R19
470
R18
1k
R17
100
R7
27k
C7
0.01
CP284
R34
10
R20
1k
15.3 MHz: 1.40 Vp-p
D3
MA2S111
C12
100p
C9
9p
D2
HVC362
C21
0.001
W40
D37
HVC350B
D35
HVC350B
D38
HVC350B
D36
HVC350B
D33
HVC350B
D31
HVC350B
D34
HVC350B
D32
HVC350B
C33
39p
R32
1k
L51
92nH
C32
9p
R33
1k
DO1
C51
0.75p
C53
22p
DO2
S5V
CP1
D39
1SV245
R37
100k
R35
180k
C37
1.5p
C36
1
R38
47k
C34
0.001
R36
47k
LVINV
LVINV
DO1
C52
6p
C20
0.001
R22
8.2k
LVINV
LVINV
L32
67nH
Q3
2SK880
C13
47p
R15
1.2k
L34
92nH
R21
10k
Q2
2SC4215
C11
100p
L31
0.47µH
L33
0.47µH
C19
0.001
R16
56
V5FV
C55
470p
VCO CASE
R31
10
S5V
2nd_Lo
REFIN
V5FV
C49
22p
PLLIN
R13
82k
R14
47k
C48
10
C47
10
R47
2.2k
C14
0.001
X1
CR-664A 15.300MHz
R10
470k
R8
120k
L47
0.47µH
4.89V
C8
100p
R11
47k
R9
10k
C6
2.2
CP283
C10
0.1
8
7
6
5
4
3
2
1
FIN
LD
GND
DO
VCC
VP
OSCOUT
OSCIN
C17
1.5
C16
4.7
IC1 MB15A02PFV-1
PLSTB
PLSTB
Q47 XP6501
S5V
D1
MA2S111
R3 1k
SCLK
2
FHV
C2
0.1
UNLKI
UNLKI
T5V
V5V
PLL5V
LOCK: 4.85V
UNLK: 0.50V
C1
0.1
VCC
VCC
T5V
T5V
V5V
C35
470p
R39
100k
VCOS
TX: 0.0V
RX: 3.54V
J351
2nd_Lo
PLLIN
R5V
R5V
R222
1.2k
C224
2p
C226
10p
R223
150
C251
0.01
R251
470
BTYPE
Q221
2SC4116
2
C252
0.01
M5V
V5VS
R5VS
12
D231
DAN222
T5VS
FI232
CFWM450G
FI231
CFWM450E
5
R243
4.7
4
1
2
3
4
5
6
7
8
1
3
C236
0.01
3 4 5
MICO
SMICO
R236 4.7
R233
15k
R234
22k
W/NS
TEMPV
LVINV
W/NS
R5V
R235
22k
C233
0.1
CDECV
D232
DAN222
R237
12k
C234
0.1
R238
15k
R239 220k
C235
0.1
C237
120p
C238
120p
R240
47k
R241
6.8k
MIXIN
GND
N-REC
N-DET
RSSI
IFOUT
QUAD
AFOUT
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
C239
4.7
C240
0.001
R231
3.3k
C231
0.001
IC231 TA31136FN
30.6 MHz: 0.2 Vp-p
DA5V
S5V
M5V
L222
1.0µH
16
15
14
13
12
11
10
9
TX: 0.0V
RX: 3.78V
R214
470
C217
100p
R216
680
X231
CDBC450CX24
C232
100p
RSSIV
C241
0.1
MODIN
C243
0.001
31.05 MHz
R213
1.5k
RSSIV
RSSIV
C247
0.001
R245
47k
R242
390
C242
0.001
C216
0.01
R215
120k
NOISV
C245
0.001
Q232
2SC5107
UNLKI
W/NS
C215
0.001
Q211
2SC4215
R244
2.2k
DET
R246
47k
C244
0.001
C246
470p
DASTB
MOCON
EXSTB
DET
SQCON
WIDE: 0.0V
NARROW: 4.98V
SQLOUT
Q231
DTA144EU
CDTENC
VSSTB
A
PLSTB
EXOE
RSSIV
RSSIV
RSSIV
NOISV
NOISV
TDETV
TDETV
NOISV
VCOS
VCOS
T5V
TX: 0.0V
RX: 4.96V
R5V
BEEPO
M5V
T5V
R5V
9 8 7 6 5 4
Q323
2SA1588
C325
22
NC
P/S
V5V
C326
4.7
V5VS
C323
0.01
C322
0.01
R5VS
R326
4.7k
C327
4.7
C324
0.01
10
11
12
13
14
15
SCIN
LD/LTH
AT
VSS
IC
RXOUT
R5VS
T5VS
S5V
IC331 EW-460
O
G
RXOUT
Transmit
Power supply
Receive
1
2
3
4
5
6
7
8
STR
D
CLK
Q1
Q2
Q3
Q4
VSS
VDD
QE
Q5
Q6
Q7
Q8
QS
QS
SMICO
16
15
14
13
12
11
10
9
16 17 18 19 20 21
SDATA
1 MHZ
S5V
1 MHZ
TXIN
C387
1
R384
18k
R385
3.3k
C386
1
VCOS
VCOS
TXMS
ATTS
C396
1
1
2
3
4
C341
0.01
R386
100k
C389
0.01
CKSIS
R381
10k
R382
56k
C385
0.1 TXIN
IC382
NJM2904V
M5V
EXOE
C397
1
C383
1
C382
1
C384
0.1
MICO
IC341
BU4094BCFV
EXSTB
SDATA
SCLK
CTFIS
SRXMS
DETMS
CKSIS
Common
3
2
1
24
23
22
S5V
8
7
6
5
R383
100k
C388
0.01
AG3V
CKSIS
AG3V
EXSTB
RXIN
SMICO
BTYPE
MAIN UNIT
SDATA
MICO
BTYPE
C381
1
SCLK
SDATA
DETIN
C333
0.001
S5V
SCLK
R336
100k
DETOUT
SCLK
SDATA
I
SDIN
X
X/CLK
VDD
LFO/P
TXIN
IC381
FX214LG
TXOUT
T5VS
S5V
VSSTB
T5VS
SCLK
SCLK
VSSTB
VSSTB
R325
10k
TXOUT
VBIAS
RXIN
HFO
HBMI
LBMI
V5VS
R323
10k
R321
10k
R322
4.7k
S5V
SDATA
Q322
2SA1588
Q321
2SA1588
4.92V
S5V
M5V
M5V
GND
B
S5V
TX: 4.87V
RX: 0.0V
NC
NC
NC
NC
T5V
TDETV
RXIN
WDECV
EXOE
BEEPO
C225
18p
ATTS
GND
WDECV
RSSIV
NOISV
TDETV
C223
18p
TXMS
PLSTB
SDATA
SCLK
EXOE
L221
1.0µH
R221
680k
SCLK
GND
MODIN
CDTENC
GND
VSSTB
EXSTB
DASTB
C222
0.01
C221
10p
SDATA
CTFIS
GND
W/NS
TEMPV
LVINV
CDECV
UNLKI
S5V
DETMS
GND
MICO
SMICO
VCC
VOLIN
SRXMS
VOLIN
GND
BTYPE
S5V
M5V
V5VS
R5VS
T5VS
SDATA
to
LOGIC
UNIT
J401
VCC
VCC
R5V
IF5V
38
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
37
PLLIN
R232
47
C
11 - 1
VCC
VCC
T5V
L61
0.1 H
R62
68k
DO1
C56
0.01
R53
4.7
R51
2.7k
DO2
DO2
C81
12p
Q51
2SC4226
4
L82
3.3 H
C54
18p
R52
5.6k
Q62
2SC4215 R72
5
Q82
DTC144EU
VCOS
C91
9p
C73
12p
C75
56p
R193
3.3k
C194
0.022
C195
0.001
TX: 0.0V
RX: 0.89V
C203
8p
TX: 0.0V
RX: 4.20V
W202
R206
4.7k
R205
470
L181
56nH
C188
6p
DASTB
SCLK
SDATA
T4CON
22
T3CON
VIN2
VIN7
VDD
GND
20
6
7
LD
RESET
19
VDAREF
18
FRCON
11
12
DO
VIN6
VIN3
VOUT3
VOUT4
IC141
TA75S01F
Q165
3SK294
R165
100k
C184
2.5p
R184
220k
C182
82p
R185
10k
R181
820
R182
220k
R183
10k
T3CON
C144
0.01
5
R173
5.6k
C172
0.001
R167
470
C166
47p
D141
MA2S728
VOUT5
14
R146
10k
R144
2.7k
T1CON
C142
0.001
L152
50nH
C156
6p
L151
50nH
D154
HVU350B
C165
0.001
L155
56nH
R166
270k
C163
4p
C161
56p
TX: 0.0V
RX: 1.86V
T3CON
T2CON
L154
56nH
R155
220k
C153
3p
L153
1H
C158
0.001
D152
MA77
C152
10p
R151
100
R153
220k
R154
10k
T1CON
C162
0.001
C168
6p
L156
56nH
C159
2.5p
C157
27p
R156
10k
C154
0.001
D153
1SV307
R152
22k
D151
1SV307
C151
9p
ATTS
C155
0.001
S5V
S5V
S5V
C265
0.001
T2CON
T1CON
S5V
R5V
R278
27k
C253
0.01
TX: 0.0V
RX: 1.71V
R294
10k
R291
68k
R293
68k
R292
68k
IC383
TC3W03FU
1
2
3
4
CE
XT
XT
GND
VCC
B
A
Q
8
7
6
5
S5V
2.11V
AG3V
C271
47
R296
15k
R305
100k
R280
2.2k
2.11V
2.11V
C292
0.0068
Q291
XP4601
4
3
5
2
6
1
R297
10k
R298
4.7k
R264
8.2k
R263
47k
IC261
NJM2904V
C263
0.047
C266
150p
1
8
2
7
3
6
4
5
S5V
R274
2.2k
R270
15k
R267
10k
R271
56k
RXDEC
R266
5.6k
R265
10k
R306
68k
R307
1.2k
S5V
R261
4.7k
CDECV
C302
0.0022
C301
0.022
TX: 0.0V
RX: 3.61V
C294
0.0018
R262
C262 12k
0.033
C261
0.015
C293
0.033
C395
0.1
C391
0.1
R279
3.3k
R5V
S5V
R387
1M
R133
15k
Q141
DTA144EU
TX: 0.0V
RX: 3.59V
B
1 MHZ
TDETV
S5V
13 DA5V
S5V
C136
9p
C137
0.001
R145
12k
C160
1p
R131
82k
C134
24p
TXMS
TX: 0.93V
RX: 4.42V
C270
1
VOLIN
R272
150k
R273
1k
C268
0.047
C267
0.0047
R269
100k
AG3V
AG3V
AG3V
R388
1k
DET
DET
X381
CR-746
4.000 MHz
Common
Transmit
C394
120p
DET
C312
0.022
R313
39k
R315
390k
3
R314
82k
5
4
C314
820p
R316
180k
WDECV
DET
IC311
NJM2125F
C272
0.47
C316
0.047
1
8
1
8
DETIN
2
7
2
7
SRXMS
3
6
3
6
4
5
4
5
11 - 2
CDECV
WDECV
Power
supply
S5V
RXDEC
CTFIS
R283
100k
CTCS mode: 5.00V
CTFIS
MAIN UNIT
IC282
TC4W53FU
SRXMS
CKSIS
C
Receive
C281
0.01
R281
100k
C315
0.1
CKSIS
IC281
TC4W66FU
R284
100k
1
2
R312
100k
R317
1.5k
R282
100k
S5V
R275
180k
C269
0.01
R277
390k
BEEPO
R276
10k
CTFIS
AG3V
CKSIS
C311
0.001
C313
820p
S5V
VOLIN
R311
100k
Q381
DTC144EU
DETMS
BEEPO
C393
27p
R389
10k
DETMS
S5V
DETOUT
C398
12p
C392
27p
S5V
DETIN
S5V
ANT
J41
1
2
C135
7p
C138
1p
R143
2.2k
C143
0.1
CP131
R132
10k
R142
39k
C141
0.1
R147
150k
TX: 0.0V
RX: 3.22V
D171
MA2S111
C164
7p
3
L132
32nH
D132
1SS375
1
2
D155
HVU350B
C183
0.001
S5V
C132
22p
C126
18p
R141
150k
R171
10k
R172
470k
C173
47p
L166
56nH
TX: 0.0V
RX: 4.95V
C181
0.001
C291
0.01
S5V
C125
15p
16 DA5V
15
VIN5
R121
15k
S5V
R148
100
17
VOUT6
VIN4
C123
15p
C133
11p
MP111
C171
0.47
R175
10k
CTFIS
23
VOUT7
21 DA5V
DTCON
DA5V
VOUT8
VOUT2
DI
C122
8p
C121
56p
24 DA5V
VOUT1
CLK
R149
1k
Q171
2SK1829
D181
HVU350B
T4CON
S5V
4
5
8
9
10
CDTENC
C113
0.1
RSSIV
C167
0.01
C187
0.001
IC251 M62363FP-650C
VIN8
R201
1k
C201
0.001
C186
33p
R5V
S5V
C112
0.001
R114
100k
Q111
RD07MVS1
S5V
L165
1H
C185
1p
R186
4.7k
R191
120
R202
10k
R203
470
DET
VIN1
C202
27p
D182
HVU350B
R5V
3
R113
4.7k
C105
0.001
TX: 0.0V
RX: 3.22V
R204
12
W201
C189
5p
4.97V
2
C104
0.1
L131
30nH
L123
50nH
C124
0.001
4
T4CON
1
R112
10
S5V
L203
0.1 H
Q191
3SK299
C191
0.001
C192
47p
C213
6p
C193
56p
L191
0.47 H
R211
1k
31.05 MHz
MOCON
MODIN
R102
33k
R101
4.7k
C74
56p
R5V
C211
0.001
SQLOUT
SQCON
C99
0.001
C131
0.001
D121
RB706F-40
RSSIV
R192
100
L122
22nH
C107
22p
C145
0.001
R5V
DET
R98
100
R95
470
L121
10.5nH
R111
10
R103
68
RSSIV
R5V
A
R94
1.5k
D131
1SV307
C127
0.001
C111
100p
PLLIN
PLLIN
RSSIV
Q91
2SC5110
S5V
PLLIN
FI211
FL-353
W102
L124
2.7 H
L112
60nH
L102
18nH
D92
MA77
RSSIV
C210
4.7
W101
C115
0.001
C114
47p
Q101
RD01MUS1
C103
100p
C129
0.001
C128
47p
EP101
TX: 1.10V
RX: 0.36V
S5V
VCOS
L92
27 H
W92
W91
R91
1k
L72 33nH
MP41
1
2
3
R83
10k
R96
3.3k
TX: 1.87V
RX: 0.0V
Q71
2SC4215
C71
2p
1
C83
47p
C82
12p
C72
0.001
L71
0.1 H
R71
68k
3
2
R82
390
D91
MA77
220
Q81 XP1214
R81
330
TX: 4.86V
RX: 0.0V
C106
0.001
C98
0.001
C97
47p
R93
10k
C65
18p
Q61
2SC4215
L81
3.3 H
C92
0.001
C64
0.1
L62
0.1 H
R64
47k
R63
4.7
C62
7p
R97
10
R65
100
T1CON
C61
0.001
C57
0.5p
C63
0.001
C96
0.001
R92
100
TX: 3.51V
RX: 3.42V
TX: 3.52V
RX: 3.46V
ATTS
C43
12p
R42
3.9k
R61
100
T1CON
R43
4.7
C45
0.01
T2CON
C41
5p
C44
470p
C46
0.75p
DETMS
L41
80nH
C31
20p
Q41
2SC4226
R41
1.5k
C42
47p
R122
151
EP111
SRXMS
V5FV
T5V
T5V
VCO CASE
TDETV
T5V
TXMS
VCC
LEDS1
LEDS1
LEDS2
10
11
V5VS
R5VS
V5VS
R5VS
T5VS
GND
T5VS
LEDS2 1
MICO
SMICO
13
15
16
17
18
CP642
R654
680
4
LEDS1
GND
14
5
3
SMICO
CPU5V
SQL
R653
1k
2
MICO
12
S641
EVQ-PUL
R652
220
W/NS
TEMPV
TEMPV
LOINV
LOINV
CDECV
CDECV
Q651
XP1213
LED ON: 5.00V
W/NS
C643
0.01
CENC1
CENC2
CENC3
CENC1
CENC2
CENC3
PTTIN
EPTTI
PTTIN
EPTTI
BTYPE
TDEC
CP641
BTYPE
SQL
UP
DOWN
CH/WX
16/9
SCAN
H/L
TDEC
UNLKI
19
GND
MODIN
CDTENC
CDTENC
22
R611
10k
BEEPO
C612
0.022
S642
GND
23
24
25
26
27
28
29
30
31
VSSTBO
VSSTBO
EXSTBO
DASTBO
EXSTBO
DASTBO
PLSTBO
SDATAO
SCLKO
PLSTBO
SDATAO
SCLKO
EXOEO
EXOEO
C611
0.001
CP621
S646
R612
4.7k
SCRMS
UNLK
EXOE
R621
470k
C621
0.001
S644
CP622
S643
S645
S647
32
33
34
35
36
W641
CP623
UNLK
EXOE
GND
WDECV
WDECV
RSSIV
RSSIV
NOISV
TDETV
NOISV
TDETV
BEEPO
BEEPO
BEEP
C622
0.001
CP624
CP625
BEEPO
UNLK
EXSTB
EXOE
DASTB
VSSTBO
VSSTB
PLSTB
EXSTBO
EXSTB
SDATA
C664
0.047
S5V
VCC
BEEPO
DASTB
PLSTBO
PLSTB
SDATAO
SDATA
SCLKO
SCLK
R413
33k
R412
10k
R461
33k
Q444
DTC144EU
1
2
3
4
5
NC
VCC
NC
VIN
RIPPLE
POUT 10
PWGND 9
PREGND 8
PHASE 7
NF 6
R415
1.5M
R421
33
C413
0.1
VCC
C426
0.047
M5V
R431
27k
5
4
Q432
XP6501
C431
1
2
3
C432
0.1
R435
3.3k
AFOUT
ISPMS
7
EXTTXD
6
EXTRXD
5
ERESET
4
GND
3
EDETEDT
2
EXTVCC
1
AFOUT
8
7
6
5
4
3
2
1
EP459
CP459
CP458
EP458
S5V
EXTPTT
R454
10k
R453
1k
EXTMIC
EXTMIC
EXTTXD
EXTTXD
ETXD
ETXD
CP456
EXTRXD
EXTRXD
ERXDI
ERXDI
ERESET
ERESET
EXRES
EDETEDT
EXTSV
CP454
EP454 GND
EDETEDT
CP453
CP452
EP452
CP451
EP451
AFOUT
R451
47
EXTSV
EPTTI
VCC
EXTVCC
C452
0.001
CONNECTOR
UNIT
INMIC
CP457
CP455
1
2
3
OUT
VDD
VSS
COM0
COM1
COM2
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
COM0
COM1
COM2
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
C604
0.01
C605
47p
C606
0.01
EXRES
R591
10k
C591
0.01
IC591
HN58X2416TI
1
2
3
4
5
CD
4
NC
C581
0.027
8
VCC 7
WP
SCL 6
5
SDA
A0
A1
A2
VSS
R592
10k
ESCK
4
R551
10k
1
2
3
C451
0.001
C453
0.1
R452
1k
EXTPTT
C454
47p
D451
MA8062
C455
0.1
C456 D452
D453
D454
C457
0.1
MA8056 MA8056 MA8056 47p
EPTTI
Q461
UNR911HJ
INMIC
C465 R466
0.01 10k
R464
15k
R469
270k
1
2
Q553
DTC144EU
3
C464
0.1
PTT ON: 4.75
PTT OFF: 0.0V
Q462
UNR911FJ
R468
100k
R540
15k
R553
22k
C556
0.001
R478
4.7k
R535
10k
C536
0.047
C557
22
C534
820p
C531
0.047
C533
0.1
CENC2
R534
180k
CENC1
Q531
XP1213
TRANSMIT
CTCS CODE: 3.32Vp-p
CPU5V
R552
2.2k
R536
47k
CENC3
R533
56k
4
LDTFS
3
TRANSMIT CTCS: 0.08Vp-p
2
C532
0.039
1
5
R539
47k
TRANSMIT DTCS: 4.99V
LDTFS
EXRES
EXRES
ISPMS
ISPMS
ISPMS
MODIN
MODIN
MODIN
CDTENC
SMICO
TX: 2.03V
RX: 1.95V
C462
0.1
S5V
C463
0.01
R463
2.2k
R471
47k
IC471
NJM2904V
5
6
7
8
4
3
2
1
1.97V
R470
100k
MOD3V
R475
27k
R493
560k
R476
3.9k
IC481
TC4W66FU
R474
4.7k
MICO
1
2
MOD
STXMS 3
4
MOD3V
C473
0.01
R473
4.7k
S5V
C481
0.01
C471
0.01
C472
47
R477
2.2k
R481
100k
LDTFS
W/NS
W/NS
W/NS
1.97V
C466
0.1
R537
47k
C571
0.01
R532
22k
W/NS
R465
120k
EXMIC
Q532
2SC4116
C535
0.01
R572
150k
R531
22k
4.90V
Q552
XP6501
C555
0.22
R462
4.7k
PTTIN
C467
10
CPU5V
R538
1k
CTRL VIN 5
GND
NB VOUT 4
S5V
R467
470
EXRES
MICO
S5V
INMIC
PTTIN
J851
9
5
SMICO
VCC
INMIC
EXTMIC
D581
MA2S111
RES
R571
330k
CDTENC
VCC
EXTPTT
6
C561
0.01
S461
EVQ-PUL
8
R604
12k
C602
7p
C553
10
C554
0.01
R562
4.7k
R432
1M
R433
2.2k
C551
22
R561
10k
R434
2.2k
1
C427
150
C552
0.001
IC551
NJM2870
Q561
2SA1588
6
R422
C425 10
47p
TX: 0.0V
RX: 7.15V
EXRES
EXT PTT ON: 0.0V
EXT PTT OFF: 4.45V
R606
1k
R605
12k
VCC
Q551
2SB1132
AF7V
L421
EXCCL3216U1
C424
10
INT SP: 0.0V
EXT SP: 5.00V
C461
0.001
PTT
9
D601
MA77
R602
1M
ESCK
BATTV
5.00V
Q431
2SB1132
C423
0.001
TX: 0.40V
RX: 3.29V
AFOUT
CHASSIS
J41
M5VS
S5VS
AFVS
C412
0.47
R414
4.5M
C422
0.1
IC421
TA7368F
BEEPO
W462
W461
CPU5V
9.8304 MHZ: 4.32 Vp-p
S5V
8
7
6
5
MOD
R482
100k
R495
4.7k
R491
15k
1
2
3
4
C491
0.01
8
7
6
5
R494
100k
MOD3V
11 - 3
R497
180k
C492
1
R498
100k
R492
220k
ISPMS
WIDE: 0.0V
NARROW:4.97V
R512
150k
R496
220k
R511
27k
R503
C502 120k
150p
S5V
R504
10k
Q501
DTC144EU
W/NS
W522
C521
0.1
ATIS
C511
0.0033
C504
0.0015
R521
680
TX: 1.93V
RX: 1.96V
R501
100k
C503
0.0047
R513
18k
C512
0.1
R502
33k
IC491
NJM2904V
MICMS
R472
18k
STXMS
–
C411
0.47
C421
10
R443
100k
MC461
SKB-2746
INMIC
R603
12k
MICMS
R411
10k
ISPMS
Q443
CPH3403
+
C603
33p
C661
0.047
CPU5V
S5V
AF7V
AFVS
R441
470k
Q442
CPH3403
CPU5V
ESDA
W581
VCC
VCC
Q411
2SC4213
R442
470k
MP441
CPU5V
X601
CR-747
CPU5V
S5V
AFMS
SPE
C670
0.047
MODIN
S5V
CP442
C669
0.047
CDTENC
MODIN
AFOUT
SP1
C668
0.047
CPU5V
4.95V
C441
47p
C667
0.047
ESDA
R581
10k
M5V
CDTENC
AFOUT
C666
0.033
IC581
S-80942CNMC-G9C
Q441
2SC4116
C671
0.1
CDECV
TEMPV
LOINV
RSSIV
NOISV
TDETV
ESCK
MICO
S5V
CP441
ETXDO
SMICO
MICO
VOLIN
C681
0.1
C685
0.47
ERXDI
R582
1k
C582
47p
W/NS
AFMS
5
CPU5V
ATIS
ATIS
C601
22p
ERXDI
SMICO
VOLIN
VOLO
8 CPU5V
7 CONT2
6
5
5.02V
OSC1
R583
100k
M5V
1
2
3
1
2
3
4
CONT1
C684
0.47
C683
0.47
CPU5V
DASTBO
ETXD
J411
C682
0.47
C663
0.047
R601
10
R633
10k
W/NS
4
COM2
COM1
COM0
C665
0.047
R684
1.8M
EXTSV
Transmit
to
VR
UNIT
R683
390k
IC681
TC4W66FU
C662
0.047
SCLK
Receive
Power
supply
R682
270k
WDECV
VSSTB
EXOEO
R632
100k
Common
CONT2
CONT1
R681
820k
WETIN
R631
10k
UNLKI
38
IC661
µPD780316GC
SEG9
SEG8
SEG7
SEG6
SEG5
SEG4
SEG3
SEG2
SEG1
SEG0
CPU5V
CPU5V
C623
0.001
CP626
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
S9
S8
S7
S6
S5
S4
S3
S2
S1
S0
SCOM0
COM3
COM2
COM1
COM0
VLC2
VLC1
VLC0
VLCDC
CAPL
CAPH
AVREF1
P120/AO0
AVSS0
ANI9
ANI8
P17/ANI7
P16/ANI6
P15/ANI5
P14/ANI4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
MODIN
21
VSS0
VDD0
P60
P61
P62
P63
P64
P65
P66
P67
P40
P41
P42
P43
P44
P45
P46
P47
P50
P51
P52
P53
P54
P55
P56
P57
P70/TO4
P71/TI4
P72/TO52
P73/TI52
BEEP
VSSTB
EXSTB
DASTB
PLSTB
ERXDI
ETXDO
20
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
EXTSV
9
R651
330
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
W/NS
LDTFS
ISPMS
MICMS
STXMS
LEDS2
LEDS1
S5V
C642
0.01
C641
22
SQL
CSIFT
VPP
8
DS654
SML-311YT
M5V
M5V
7
DS652
FY1101F-TR
P87/S39
P86/S38
P85/S37
P84/S26
P83/S35
P82/S34
P81/S33
P80/S32
P97/S31
P96/S30
P95/S29
P94/S28
P93/S27
P92/S26
P91/S25
P90/S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
BTYPE
S5V
6
DS653
SML-311YT
LED ON: 5.00V
BTYPE
5
DS651
FY1101F-TR
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
S5V
S5V
GND
4
to
MAIN
UNIT
J351
VCC
VOLIN
VOLIN
P30/TO0
P31/TI00
P32/TI01
P33/TO50/TI50
P34/TO51/TI51
P20/RXD0/SI3
P21/TXD0/SO3
P22/SCK3
P23/SI1
P24/SO1
P25/SCK1
P00/INTP0
P01/INTP1
P02/INTP2
P03/INTP3/ADTRG
P04/INTP4
P05/INTP5/BUZ/PCL
VPP
XT2
XT1
VSS1
VDD1
X2
X1
RESET
AVREF0
P10/ANI0
P11/ANI1
P12/ANI2
P13/ANI3
VCC
VCC
2
3
CONT1
T5VS
R5VS
V5VS
S5VS
M5VS
AFVS
AFMS
W/NS
37
1
DS681
L2-0390TAY
CONT2
W/NS
SDATA
SCLK
ESCK
ESDA
J401
W/NS
CPU5V
OSC2
OSC1
RES
CPU5V
WDECV
WETIN
EXTSV
BATTV
LOGIC UNIT
LEDS2
C522
0.022
W523
MODIN
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : +81 (06) 6793 5302
Fax
: +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
Icom America Inc.
Icom (Europe) GmbH
<Corporate Headquarters>
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : +1 (425) 454-8155
Fax : +1 (425) 454-1509
URL : http://www.icomamerica.com
E-mail : [email protected]
<Customer Service>
Phone : +1 (425) 454-7619
Communication Equipment
Himmelgeister Str. 100, D-40225 Dusseldorf, Germany
Phone : +49 (0211) 346047
Fax : +49 (0211) 333639
URL : http://www.icomeurope.com
Icom Canada
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : +1 (604) 952-4266
Fax : +1 (604) 952-0090
URL : http://www.icomcanada.com
Icom (Australia) Pty. Ltd.
A.B.N. 88 006 092 575
290-294 Albert Street, Brunswick, Victoria, 3056, Australia
Phone : +61 (03) 9387-0666
Fax : +61 (03) 9387-0022
URL : http://www.icom.net.au
Icom New Zealand
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : +64 (09) 274 4062
URL : http://www.icom.co.nz
Icom Spain S.L
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
Phone : +34 (93) 590 26 70
Fax : +34 (93) 589 04 46
URL : http://www.icomspain.com
Icom (UK) Ltd.
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : +44 (01227) 741741
Fax : +44 (01227) 741742
URL : http://www.icomuk.co.uk
Icom France S.a
Zac de la Plaine, 1, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
Phone : +33 (5) 61 36 03 03
Fax : +33 (5) 61 36 03 00
URL : http://www.icom-france.com
Asia Icom Inc.
Fax : +64 (09) 274 4708
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : +886 (02) 2559 1899
Fax : +886 (02) 2559 1874
URL : http://www.asia-icom.com
Beijing Icom Ltd.
Icom Polska
1305, Wanshang Plaza, Shijingshan Road, Beijing China
Phone : +86 (010) 6866 6337
Fax : +86 (010) 6866 3553
URL : http://www.bjicom.com
Sopot, 3 Maja 54 Poland
Phone : +48 (58) 550 7135
Fax : +48 (58) 551 0484
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-13909MZ-C2-q
© 2002–2004 Icom Inc.

IC-M88 Service Manual - R

Transcription

Similar documents

not doing a thing about it

Icom IC-2720H Service manual

IC-756 Pro3 Service manual

ic-m802 service manual

IC-F21/F22 series Service Manual

IC-706MKIIG service manual

Icom IC-718 Service Manual

Icom IC - 706 - Bodi Krumlov