Innovator III Doors for Walk-In Coolers

Transcription

IWL3067R
IWM3067R
INNOVATOR & INNOVATOR III
DOOR SYSTEM
FOR WALK-IN COOLERS
Technical Data Sheet
P/N 0520888_C
April 2013
One to Five Doors per Frame, Left or Right Hinge
HUSSMANN/AMERICAN
Arroz 155
Iztapalapa, México D.F. 09820
Tel: 85 03 19 00
NOTE:
Revision C adds EcoShine II Plus LED lights.
©2012 HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-890-2900 • WWW.HUSSMANN.COM
Spanish 0538955
French 0538956
Innovator Doors are designed for use in areas where temperature
does not exceed 75ºF (24ºC) and relative humidity does not exceed
55%.
IWL3067R
IWM3067R
Innovator Door and Frame
Net Opening Width (from formula on page 3) +0.25 / – 0
When determining net opening dimensions, remember that a slightly oversized opening may be filled
easily with insulating foam. Enlarging an undersized opening is time consuming and may affect the
structural integrity of cooler panels.
Product Code
I WXXXXXX–XXX
Innovator Product Family
Walk-In Cooler
Temperature Application
L = Low
M = Medium
Nominal Door Width (inches)
Nominal Frame Height (inches)
Door Frame
R = RIM Molded
A = Aluminum
Number of Openings in Frame
Letter and Number designations used for color and trim options
Frame Dimensions
IWL3067R or IWM3067R Frame Width — to be used in formula on Page 3
1 Door
31.5 in. (800 mm)
2 Doors
61.938 in. (1574 mm)
3 Doors
92.375 in. (2347 mm)
4 Doors
122.813 in. (3120 mm)
5 Doors
153.25 in. (3893 mm)
IWL3067 or IWM3067 Frame Height
Page 2
67.5 in. (1715 mm)
IWL3067R and
IWM3067R
HUSSMANN/AMERICAN • Arroz 155 • Iztapalapa, México D.F. 09820 • Tel: 85 03 19 00
Innovator Walk-In Cooler, Low Temperature, 30 in. Width, 75 in. Height
FOR
NET OPENING WIDTH FORMULA
1 TO 4 FRAMES WITH 1 TO 5 DOORS PER
FRAME
Consult cooler wall manufacturer to determine the
maximum number of continuous doors
allowed in a lineup between mullion supports.
IWL3067R
IWM3067R
Using the illustration below as an example, the formula for a three frame assembly of two doors each gives
Clearance LH + Frame Width + Join + Frame Width + Join + Frame Width + Clearance RH = Net Opening Width
0.188 +
61.938 + 0.125 +
61.938 + 0.125 + 61.938 +
0.188
= 186.44 in. Net Opening
Width (frame width from Page 2). Using a two frame assembly of three doors each would require a smaller net opening of 185.243 in. Always use the fewest frames possible to achieve the number of doors required.
P/N 0520888_A
U.S. & Canada 1-800-922-1919 • Mexico 1-800-522-1900 • WWW.HUSSMANN.COM
Page 3
IWL3067R
IWM3067R
Innovator Door and
Frame
Page 4
IWL3067R and
IWM3067R
IWL3067R
IWM3067R
Description
LED Power Supply
Clip LED, Center
Clip LED, End
LED Lamps (Replace with like fixtures, sizes and light temperatures shown below.)
LED Vertical 4000K 68 in.
Contact your
Door–Innovator, Medium Temperature, Black, LH
Door–Innovator, Medium Temperature, Black, RH
Door–Innovator, Medium Temperature, Gray, LH
Door–Innovator, Medium Temperature, Gray, RH
Door–Innovator, Low Temperature, Black, LH
Door–Innovator, Low Temperature, Black, RH
Door–Innovator, Low Temperature, Gray, LH
Door–Innovator, Low Temperature, Gray, RH
NOTE: GLASS AND GLASS HEATERS ARE NOT FIELD REPLACEABLE.
Hussmann supplier,
Hussmann service organization or
Hussmann representative to obtain
replacement parts.
To find your nearest Hussmann
location, go to:
www.hussmann.com/locations
Handle, Black
Handle, Gray
Screw-Handle
Gasket, Magnetic, Black
Gasket, Magnetic, Gray
Torsion Rod Assembly, Bottom, LH
Torsion Rod Assembly, Bottom, RH
Pin, Top Hinge
Spring, Hinge Pin Coil
Shoulder Screw, Hold-open, Black
Shoulder Screw, Hold-open, Gray
Molding, End
Molding, Joint
Binder Post & Screw
Wireway Cover
P/N 0520888_A
Page 5
IWL3067R
IWM3067R
Normal Duty Shelf
(loads of 100 – 150 lb)
Heavy Duty Shelf
(loads of 150 – 200 lb)
Variable Position Shelf
(loads up to 300 lb)
Shelving Accessory Identifier
Drip Pan
Front & Side Guard
Shelf Divider
Post Spacer
Shelf Perimeter Guard
Mobile
Merchandiser
Step Shelf
Basket Shelf
Page 6
Variable Position Perimeter Guard
Post with Leveler Bracket
IWL3067R and
IWM3067R
IWL3067R
IWM3067R
Wiring diagrams are provided in the
Innovator I, Innovator II and Innovator III
Door System Installation & Service Manual,
P/N 0520886, available at
http://www.hussmann.com/ServiceAndParts/
TechnicalInformation/Pages/Walk-InDoors
IWL3067R
REFRIGERATION DATA
Additional Capacity
ELECTRICAL DATA
745 Btu/hr/door
Anti-sweat Heaters
Doors – 120V 60Hz
Doors – 220V 50Hz
Frames – 120V 60Hz
Vertical Lighting
EcoShine II – 120V 60 Hz
Fluorescent – 120V 60 Hz
1
Door
2
Door
0.42
NA
0.40
0.21
0.83
NA
0.78
0.43
0.18
0.10
1.00
0.46
0.36
0.20
1.50
0.84
3
Door
4
Door
Amperes
1.25
1.67
NA
NA
1.18
1.57
0.64
0.85
5
Door
1
Door
2
Door
3
Door
4
Door
5
Door
2.08
NA
1.97
1.07
50
NA
48
46
100
NA
94
95
Watt
150
NA
142
141
200
NA
188
187
250
NA
236
235
0.54
0.29
2.00
1.12
0.72
0.39
2.50
1.40
0.90
0.49
3.00
1.68
22
22
120
101
43
43
180
185
65
65
240
246
86
86
300
308
108
108
360
370
3
Door
4
Door
5
Door
1
Door
2
Door
3
Door
4
Door
5
Door
NA
94
95
NA
118
119
86
86
300
308
108
108
360
370
IWM3067R
REFRIGERATION DATA
Additional Capacity
450 Btu/hr/door
ELECTRICAL DATA
Anti-sweat Heaters
Doors
Vertical Lighting
P/N 0520888_A
1
Door
2
Door
N.A
0.20
0.11
Amperes
N.A
N.A
N.A
0.39
0.59
0.78
0.21
0.32
0.43
N.A
0.98
0.54
NA
24
24
NA
47
46
Watt
NA
71
70
0.18
0.10
1.00
0.46
0.36
0.20
1.50
0.84
0.90
0.49
3.00
1.68
22
22
120
101
43
43
180
185
65
65
240
246
0.54
0.29
2.00
1.12
0.72
0.39
2.50
1.40
Page 7
IWL3067R
IWM3067R
Innovator I and III
Low Temperature Doors
Only
Page 8
IWL3067R and
IWM3067R
IWL3067R
IWM3067R
Conduit from Wireway
Each frame has the following wires in flexible
conduit:
A. LOW TEMPERATURE APPLICATION ONLY —
The Door Heater Harness is made of two
joined black wires.
B. The Frame Heater Harness is made of two
separate black wires OR one black and one
white wire; one or both will have a part
number stamped visibly along the length of
the wire.
C. The Power Supply Harness has one white
wire and one black wire bound with
Tiewrap.
D. The Ground wire is green.
This photo shows the wiring with lables added
for clarity. The diagram shows how the wires
must be connected.
Part Number
A
Conduit from
Wireway
B
ss
ter Harne
Door Hea
Frame Heater Harness
D Ground
C
Tie-Wrap
P/N 0520888_A
Power
Supply
Harnes
s
Page 9
Hussmann Corporation
12999 St. Charles Rock Road
Bridgeton, MO 63044
www.hussmann.com

Innovator III Doors for Walk-In Coolers

Transcription

Similar documents