disassembly procedures

HK 3380 HK3480 Stereo Receiver
SERVICE MANUAL
SPEAKER 1
SPEAKER 2
MUTE
AUTO
TUNED
STEREO
RDS
PTY
CT
RT
TA
MEMORY
PRESET
SLEEP
PHONO
FM
AM
CD
VID 1
VID 2
VID 3
TAPE M.
Power for the Digital Revolution®
Technical Specifications HK3380/230
Audio Section
FM Tuner Section
Stereo Mode
Continuous Average Power (FTC)
80 Watts per channel, 20Hz –20kHz
@ < 0.07% THD, both channels driven into 8 ohms
100 Watts per channel, 20Hz –20kHz
@ < 0.2% THD, both channels driven into 4 ohms
Input Sensitivity/Impedance
Linear (High Level)
200mV/47kohms
Signal-to-Noise Ratio (IHF-A)
95dB
Frequency Response
@ 1W (+0dB, –3dB)
10Hz –110kHz
High Instantaneous
Current Capability (HCC)
±42 Amps
Transient Intermodulation
Distortion (TIM)
Unmeasurable
Rise Time
16 µsec
Slew Rate
40V/µsec
Frequency Range
Usable Sensitivity
Signal-to-Noise Ratio
Distortion
Stereo Separation
Selectivity
Image Rejection
IF Rejection
87.5–108MHz
IHF: 1.12 µV/13.5dBf
Mono/Stereo: 73/72dBA (DIN)
Mono/Stereo: 0.3/0.4%
40dB @ 1kHz
±400kHz, 65dB
>80dB
>100dB
AM Tuner Section
Frequency Range
Signal-to-Noise Ratio
Usable Sensitivity
Distortion
Selectivity
520 –1710kHz
>40dB
Loop: 500µV/M
1kHz, 50% Mod: 0.8%
±10kHz: >25dB
Video Section
Television System
Signal Format
Input Level
Input Impedance
Sync Polarity
Output Level
Output Impedance
Video Frequency
Response
NTSC/PAL/SECAM
Composite
1Vp-p
75 ohms, unbalanced
Negative
1Vp-p
75 ohms, unbalanced
10Hz – 10MHz
General
Power Requirement
Power Consumption
AC 230V/50Hz
3W standby, 200W maximum
(both channels driven)
Dimension (Max)
Width
Height
Depth
Weight
442mm
168mm
382mm
9.5kg
Depth measurement includes knobs, buttons and terminal connections. Height measurement includes feet and chassis.
All features and specifications are subject to change without notice.
Harman Kardon and Power for the Digital Revolution are registered trademarks of Harman International Industries, Incorporated.
TECHNICAL SPECIFICATIONS HK3380
Technical Specifications HK3480
Audio Section
FM Tuner Section
Stereo Mode
Continuous Average Power (FTC)
100 Watts per channel, 20Hz –20kHz
@ < 0.07% THD, both channels driven into 8 ohms
135 Watts per channel, 20Hz –20kHz
@ < 0.2% THD, both channels driven into 4 ohms
Input Sensitivity/Impedance
Linear (High Level)
200mV/47kohms
Signal-to-Noise Ratio (IHF-A)
95dB
Frequency Response
@ 1W (+0dB, –3dB)
10Hz –110kHz
High Instantaneous
Current Capability (HCC)
±40 Amps
Transient Intermodulation
Distortion (TIM)
Unmeasurable
Rise Time
16 µsec
Slew Rate
40V/µsec
Frequency Range
Usable Sensitivity
Signal-to-Noise Ratio
Distortion
Stereo Separation
Selectivity
Image Rejection
IF Rejection
87.5–108MHz
IHF: 1.12 µV/13.5dBf
Mono/Stereo: 71/67dBA (DIN)
Mono/Stereo: 0.3/0.4%
40dB @ 1kHz
±300kHz, 60dB
>80dB
>100dB
AM Tuner Section
Frequency Range
Signal-to-Noise Ratio
Usable Sensitivity
Distortion
Selectivity
520 –1710kHz
>40dB
Loop: 500µV/M
1kHz, 50% Mod: 0.8%
±9kHz: >25dB
General
Power Requirement
Power Consumption
Dimension (Max)
Width
Height
Depth
Weight
AC 230V/50Hz
72W idle, 470W maximum
(both channels driven)
442mm
156mm
415mm
12.1kg
Depth measurement includes knobs, buttons and terminal connections. Height measurement includes feet and chassis.
All features and specifications are subject to change without notice.
Harman Kardon is a registered trademark, and Power for the digital revolution is a trademark, of Harman Kardon, Inc.
VMAx is a registered trademark of Harman International Industries, Inc., and is an implementation of Cooper Bauck Transaural Stereo under patent license.
TECHNICAL SPECIFICATIONS HK3480
DISASSEMBLY PROCEDURES
<1> TOP-CABINET(21) REMOVAL
1. Remove 13 screws(S1) and then remove the Top-cabinet.
<2> FRONT PANEL ASS’Y REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Disconnect the lead wire(BN71-12P,BN72-5P) on the Tone PCB(38) from connector(CN71,CN72) on the
Main PCB(44).
3. Disconnect the lead wire(BN82-7P) on the Front PCB(37) from connector(CN82) on the Main PCB(44).
4. Disconnect the connector(CN81-20P wire assy) on the Front PCB(37) from connector(CN81)
on the Main PCB(44).
5. Disconnect the lead wire(BN73-3P) on the Phone PCB(40) from connector(CN73) on the Main PCB(44).
6. Disconnect the lead wire(BN89-7P) on the Front PCB(37) from connector(CN73) on the Download PCB(44).
7. Remove 1 screw(S10) and then lead wire(JW73-2P) on the Phone PCB(40).
8. Remove 1 screw(S10) and then lead wire(JW72-1P) on the Tone PCB(38).
9. Remove 9 screws(S1) and then remove the Front Panel ASS’Y.
<3> TONE PCB(38) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Remove the Front Panel ASS’Y, referring to the previous step<2>.
3. Pull out the Volume Knob ASS’Y & 3 Rotary Knobs(5).
4. Remove 9 screws(S1,S11) and then remove the Tone PCB(38).
5. Disconnect the lead wire(BN83-4P) from connector(CN83) on the Tone PCB(38).
<4>PHONE PCB(40) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Remove the Front Panel ASS’Y, referring to the previous step<2>.
3. Remove 2 screws(S2,S3) and then remove the Phone PCB(16).
<5>POWER LED PCB(39) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Remove the Front Panel ASS’Y, referring to the previous step<2>.
3. Remove 2 screws(S2) and then remove the Power led PCB(39).
4. Disconnect the lead wire(BN84-4P) from connector(CN84) on the Power led PCB(39).
<6>FRONT PCB(37) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Remove the Front Panel ASS’Y, referring to the previous step<2>.
3. Remove the Tone PCB(38), referring to the previous step<3>.
4. Remove the Phone PCB(40), referring to the previous step<4>.
5. Remove the Power led PCB(39), referring to the previous step<5>.
6. Remove 13 screws(S2) and then remove the Front PCB(37).
<7>TUNER MODULE(34) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Disconnect the connector(CON1-Card cable) from connector(CN26) on the Main PCB ASS’Y(44).
3. Remove 2 screws(S8) and then remove the Tuner Module(34).
<8>VIDEO PCB(43) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Disconnect the connector (CN91) on the Main PCB ASS’Y(44) from lead wire(BN91-9P)
on the Video PCB(43).
3. Remove 4 screws(S8,S13) and then remove the Video PCB(43).
<9>DOWNLOAD PCB(42) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Disconnect the connector (CN89) from lead wire(BN89-7P) on the Front PCB(37).
3. Remove 2 screws(S4) and then remove the Download PCB(42).
<10>POWER TRANS(30) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Disconnect the connector (CN62,CN63,CN64) on the Trans PCB from lead wire(BN62-2P,BN63-3P,BN64-6P)
on the Main PCB(44).
3. Remove 4 Trans screws(S9) and then remove the Power Trans(30).
<11>MAIN PCB ASS’Y(44) REMOVAL
1. Remove the Top-cabinet, referring to the previous step<1>.
2. Remove the Power Trans(30), referring to the previous step<10>.
3. Disconnect the connector(CN81-20P wire ass’y) from connector(CN81-7P) on the Front PCB(37).
4. Disconnect the connector(CN82) from lead wire(BN82-7P) on the Front PCB(37).
5. Disconnect the connector(CN71) from lead wire(BN71-12P) on the Tone PCB(38).
6. Disconnect the connector(CN72) from lead wire(BN72-5P) on the Tone PCB(38).
7. Disconnect the connector(CN73) from lead wire(BN73-3P) on the Phone PCB(40).
8. Disconnect the connector(CN91) from lead wire(BN91-9P) on the Video PCB(43).
9. Disconnect the connector(CN26-Card cable) from lead wire(CON1) on the Tuner Module(34).
10. Disconnect the connector(CN61) from Power cord(35).
11. Remove 21 screws(S8-11EA, S13-1EA, S4-2EA, S6-2EA, S15-1EA, S12-3EA, S5-1EA) and then
remove the Main PCB ASS’Y(44).
HK3380/230
HK3480/230
HK3380/230 EXPLODED VIEW
HK3480/230 EXPLODED VIEW
HK3380/230
HK3480/230
REF NO.
▶CAPACITOR
C603,604,605,606
C701,702,711~714
C802,817
C703,704,726
C707, 708
C709,710,813,814
C715,716,719,720
C717,718
C721,722
C723,724
C727,744,808,809
C819,838,839,914
C728,729,730,804
C811,815,816,818
C830,834,837,911
C912,828
C741,742
C745
C801
C803,812
C805,806
C807,823,824,840
C810, 829
C820
C821
C822
C831
C832,833
C835
C904~908
C909,910,921,922
C913
C825, 826
C827
▶DIODE
D701~705
D706
D707,708,802~808
D901~903
▶COIL
L801
▶TRANSISTOR
Q801,803,805,807
Q808,813
Q802,806,814,901
Q804
Q809
Q810
Q811,812
FRONT PCB CUP11653Y (VIDEO PCB CUP11653-7)
PART NO.
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
HCQI1H473JZT
CAP , MYLAR
0.047UF 50V J
CCEA1HKS100T
CAP , ELECT
UF10 50V KS
HCBS1H101KBT
CCEA1CKS470T
HCBS1H470JT
KCFE1J183JBT
KCFE1J823JBT
KCFE1J332JBT
HCBS1H221KBT
CAP , CERAMIC
CAP , ELECT
CAP , CERAMIC
CAP , FILM
CAP , FILM
CAP , FILM
CAP , CERAMIC
100PF 50V K
47UF/16V
47PF 50V J
0.018UF 63V J
0.082UF 63V J
0.0033UF 63V J
220PF 50V K
HCBS1H104ZFT
CAP , CERAMIC
0.1UF 50V Z
HCBS1H223ZFT
CAP , CERAMIC
0.022UF 50V Z
HCQI1H122JZT
HCBS1H103ZFT
CCKT1H104ZF
CCEA1AH471T
HCBS1H150JCT
HCBS1H821KBT
CCEA1AKS101T
CCEA1CH331T
CCEA1CKS4R7T
HCBS1H151KBT
CCEA1CKS2R2T
HCBS1H102KBT
CCEA0JH102T
CCKT1H101KB
CCEA1CH101T
CCEA1EH220T
HCBS1H390JT
HCBS1H561KBT
CAP , MYLAR
CAP , CERAMIC
CAP , CERAMIC
CAP , ELECT
CAP , CERAMIC
CAP , CERAMIC
CAP. ELECT
CAP , ELECT
CAP. ELECT
CAP , CERAMIC
CAP , ELECT HK3480 only
CAP , CERAMIC
CAP , ELECT
CAP , CERAMIC
CAP , ELECT
CAP , ELECT
CAP , CERAMIC
CAP , CERAMIC
1200PF 50V J
0.01UF 50V Z
50V 0.1UF
470UF 10V
15PF 50V
820PF 50V K
100UF 10V
330UF 16V
4.7UF 16V
150PF 50V K
2.2UF 16V
1000PF 50V K
1000UF 6.3V
100PF 50V KB
100UF 16V
22UF/25V
39PF 50V J
560PF 50V K
CVD52CSBBCEAB2 BLUE L.E.D
CVD50BOGDWGA
L.E.D , 2 COLOR
HVD1SS133MT
DIODE
1SS133T-77
HLQ02C100KT
COIL , AXAIL
HVTKRC107MT
T.R
KRC107M
HVTKRA107MT
HVTKTA1271YT
KVTKSA1175YT
KVTKSC2785YT
HVTKSC945CYT
T.R
T.R
T.R
T.R
T.R
KRA107M
KTA1271Y
KSA1175Y
KSC2785Y
KSC945CY
REF NO.
▶RESISTOR
R705,706,829,830
R870,918,871
R701,702,707,708
R709,710,723,724
R711,712
R713,714
R715,716,919
R717,718,824,872
R719,720
R721,722,745
R725,901~905
R726
R727,728,820,856
R866
R729,809,825~827
R835,853,860,863
R908,911,912,913
R873,874
R733,734
R742,828,833,834
R836,909,910,877
R744
R801
R806,807,808,822
R823,837~839,841
R842,845,847~852
R876,818
R831,832,844,846
R843,857,867,906
R907,917
R854,861,864
R855,862,865
R858,868
R859,869
R875
R878
R915
R916
R920
R921,922
▶TACT SWITCH
S701,801~819
▶WIRE ASS'Y
BN71
BN72
BN73
BN82
BN83,84
BN89
BN91
BN81
FRONT PCB CUP11653Y (VIDEO PCB CUP11653-7)
PART NO.
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
CRD20TJ101T
RES , CARBON
100 OHM 1/5W J
CRD20TJ104T
RES , CARBON
100K OHM 1/5W J
CRD20TJ105T
CRD20TJ223T
CRD20TJ392T
CRD20TJ222T
CRD20TJ681T
CRD20TJ471T
CRD20TJ750T
CRD20TJ560T
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
1M OHM 1/5W J
22K OHM 1/5W J
3.9K OHM 1/5W J
2.2K OHM 1/5W J
680 OHM 1/5W J
470 OHM 1/5W J
75 OHM 1/5W J
56 OHM 1/5W J
CRD20TJ272T
RES , CARBON
2.7K OHM 1/5W J
CRD20TJ102T
RES , CARBON
1K OHM 1/5W J
CRD20TJ331T
RES , CARBON
330 OHM 1/5W J
CRD20TJ100T
RES , CARBON
10 OHM 1/5W J
CRD20TJ181T
CRD20TJ122T
RES , CARBON
RES , CARBON
180 OHM 1/5W J
1.2K OHM 1/5W J
CRD20TJ103T
RES , CARBON
10K OHM 1/5W J
CRD20TJ472T
RES , CARBON
4.7K OHM 1/5W J
CRD20TJ332T
RES , CARBON
3.3K OHM 1/5W J
CRD20TJ152T
CRD20TJ182T
CRD20TJ562T
CRD20TJ752T
CRD20TJ820T
CRD20TJ273T
CRD20TJ271T
CRD20TJ470T
CRD20TJ473T
CRG2ANJ470H
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , METAL OXIDE FILM
1.5K OHM 1/5W J
1.8K OHM 1/5W J
5.6K OHM 1/5W J
7.5K OHM 1/5W J
82 OHM 1/5W J
27K OHM 1/5W J
270 OHM 1/5W J
47 OHM 1/5W J
47K OHM 1/5W J
47 OHM 2W J
HST1A020ZT
SW , TACT
CWZHK3380BN71
CWZHK3380BN72
CWB2B903350EN
CWB2B907350EN
CWB2B904070EN
CWB2B907160EN
CWB2B909200EN
CWZHK3380BN81
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
REF NO.
▶CONNECTOR
CN62
CN63
CN64
CN81
CN83,84
CN89
CN90
▶F.I.P
FIP1
▶I.C
IC71
IC81
IC82
IC83
IC84
IC85
IC87
IC88
IC91
IC92
▶JACK
JK71
JK72
JK91
JK92
JK93,94
JW72
JW73
▶REMOCON SENSER
RC81
▶VARIABLE RESISTOR
VR71,72
VR73
▶ENCODER
VR81
▶CRYSTAL
X801
X802
FRONT PCB CUP11653Y (VIDEO PCB CUP11653-7)
PART NO.
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
KJP02GA89ZM
KJP03GA90ZM
KJP06GA01ZM
CJP20GB163ZW
KJP04GA19ZM
KJP07GA19ZM
KJP07HA37ZM
WAFER
WAFER
WAFER
WAFER
WAFER
WAFER
WAFER
MOLEX35328-02
MOLEX35313-0310
MOLEX 5267-06A
HFLHCA16ML08-1
F.I.P
HVINJM2068MDTE1
HVIST72F321R
BVISAA6579TV1
HVIAT24C08N10SC
HVIS-80145ALMC
HVIRE5VL28CATZ
HVIL7805CP
HVIL7905CP
HVINJM2296M
BVIKP1010B
I.C , OP AMP
I.C , FLASH U-COM
I.C , RDS FILTER
I.C
I.C RESET
I.C , RESET
I.C, REGULATOR
I.C, REGULATOR
I.C , VIDEO SW
I.C, PHOTO COUPLER
CJJ2E026Z
CJJ4S023Y
CJJ4N043Z
CJJ4S010Z
CJJ2D008Z
CWE8202110RV
CWZAVR2550JW82
JACK , HEADPHONE
JACK , BOARD
JACK , BOARD
JACK , BOARD
JACK , STEREO
WIRE, ASS'Y
WIRE , ASS'Y
HRVKSM603TH2
REMOCON SENSER CN
KSM-603TH2
CVV2X07C104Z
CVV2X05M104Z
RES , VARIABLE(TONE)
RES , VARIABLE(BALANCE)
RK14128030214C
RK14128030214Y
HSR2A026Z
VR , ENCODER
HOX04000E150C
HOX04332E200C
CRYSTAL , 4MHZ
CRYSTAL , 4.332MHZ
MOLEX53014-0710
NJM2068MD-TE1
SAA6579T/V1
AT24C08N10SC2.7
S-80145ALMC
NJM2296M
REF NO.
▶CAPACITOR
C101,102,105,106
C103,104,117,118
C191~194,301,302
C107,108,111,112
C121,122,123,124
C175,176,181,182
C195,196,219,220
C305,306
C307~310
C109,110,213,214
C222
C113,114,331~336
C115,116
C119,120
C125~130
C131~144
C145,146
C183~185,303,304
C197,198,342,615
C616,623,624,627
C201~204
C211,212,215
C216,341,620
C240
C311,312
C313,314
C315,316,317
C318
C319,320,607~609
C343
C351,352
C401,402,405,406
C409
C613,614,622
C619,629
C626
C628,630
C307~310
C601,602
C601,602
C611
C612
C621
C625
C631
C632
▶DIODE
D101~110,112~115
D301~309,606,612
D613,614
D602~605,607,615
D616~618
D608,609
D611
D601
PCB, MAIN
PART NO.
CUP11654Y
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
CCKT1H101KB
CAP , CERAMIC
100PF 50V KB
CCEA1VH100T
CAP , ELECT
10UF 35V
CCEA1CH101T
CAP , ELECT
100UF 16V
HCEA1JH471E
CAP , ELECT HK 3480 only
470UF 63V
HCQI1H102JZT
CAP , MYLAR
1000PF 50V J
HCQI1H562JZT
HCQI1H152JZT
HCQI1H183JZT
HCBS1H471KBT
HCBS1H221KBT
HCBS1H104ZFT
CCKT1H471KB
CAP , MYLAR
CAP , MYLAR
CAP , MYLAR
CAP , CERAMIC
CAP , CERAMIC
CAP , CERAMIC
CAP , CERAMIC
5600PF 50V J
1500PF 50V J
0.018UF 50V J
470PF 50V K
220PF 50V K
0.1UF 50V Z
470PF 50V KB
CCKT1H223ZF
CAP , CERAMIC
0.022UF 50V ZF
HCBS1H101KBT
CAP , CERAMIC
100PF 50V K
CCEA1HH4R7T
CAP , ELECT
4.7UF 50V
CCEA1HH1R0T
HCBS1H120JCT
HCBS1H330JT
CCEA1HH100TS
CCEA1HH100T
HCQI1H473JZT
CCEA1AH471T
HCBS1H681KBT
CCEA1EH470T
KCFE1J334JBT
CCEA1EH101T
CCEA1HH470T
CCEA1AH101T
HCBS1H103ZFT
CCEA1JH221E
CCET63VKL5103NK
CCET63VKL5153NK
HCEA1EH332E
CCEA1EH222E
KCKDKS472ME
CCEA1EH102E
BCQE2E104KDE
CCEA1JH101E
CAP , ELECT
CAP , CERAMIC
CAP , CERAMIC
CAP , ELECT
CAP. ELECT
CAP , MYLAR
CAP , ELECT
CAP , CERAMIC
CAP , ELECT HK 3480 only
CAP , FILM HK 3480 only
CAP , ELECT
CAP , ELECT
CAP , CERAMIC
CAP , ELECT
CAP , ELECT HK 3380 only
CAP , ELECT HK 3480 only
CAP , ELECT
CAP. ELECT.
CAP , CERAMIC(X1/Y2/SC)
CAP , ELECT
CAP , LINE ACROSS
CAP , ELECT
1UF 50V
12PF 50V J
33PF 50V
10UF/50V 105'C
10UF/50V
0.047UF 50V J
470UF 10V
680PF 50V K
47UF 25V
0.33UF 63V J
100UF 25V
47UF/50V
100UF 10V
0.01UF 50V Z
220UF 63V
10000/63V
15000UF 63V
3300UF 25V
2200UF 25V
0.0047UF/2.5KV
1000UF 25V
0.1UF 250V KD
100UF 63V
HVD1SS133MT
DIODE
1SS133T-77
KVD1N4003ST
DIODE
1N4003
HVDMTZJ15BT
HVDMTZJ6.2BT
HVDGBJ806MF
DIODE , ZENER
DIODE , ZENER
DIODE , BRIDGE
15V 1/2W
6.2V 1/2W
REF NO.
▶COIL
L101,102
▶TRANSISTOR
Q204~208
Q209,332,337,338
Q602
Q210,335,336
Q301~306,311,312
Q307~310
Q323,324,333,334
Q601
Q331
Q603
Q313,314
Q315,316
Q317
Q318
Q319
Q320
Q321
Q322
▶RESISTOR
R101,102,359,360
R363,364,386
R103~106,117,118
R213,214,221,222
R618
R107,108,121,123
R124,171,172,181
R182,195,196,201
R202~204,219,220
R109,110
R111,112,173,174
R367,368,385
R113,114
R115,116,125~144
R183~185,211,305
R306
R122
R151~164
R191~194,205~208
R212
R215,216
R217,218,617
R223,224,315~318
R384
R234
R235~239
R240,365,366
R241
R255
R303,304,319,320
R383
PCB, MAIN
PART NO.
CUP11654Y
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
HLQ02C470KT
COIL , AXAIL
HVTKTC2874BT
T.R , MUTE
KTC2874B
HVTKRA107MT
T.R
KRA107M
HVTKRC107MT
HVTKTC3200GRT
HVTKTA1268GRT
T.R
T.R
T.R
KRC107M
KTC3200GR
KTA1268GR
KVTKSC2785YT
T.R
KSC2785Y
KVTKSA1175YT
HVTKTA1271YT
HVTKTA1360Y
HVTKTC3423Y
HVTKTC3114A
HVTKTC3114A
BVT2SD2401P
BVT2SD2401P
BVT2SB1570P
BVT2SB1570P
T.R
T.R
T.R , PRE DRIVE
T.R , PRE DRIVE
T.R , BIAS
T.R , BIAS
T.R , POWER(DARINGTON)
T.R , POWER(DARINGTON)
T.R , POWER(DARINGTON)
T.R , POWER(DARINGTON)
KSA1175Y
KTA1271Y
KTA1360Y
KTC3423Y
KTC3114A
KTC3114A
CRD20TJ102T
RES , CARBON
1K OHM 1/5W J
CRD20TJ104T
RES , CARBON
100K OHM 1/5W J
CRD20TJ101T
RES , CARBON
100 OHM 1/5W J
CRD20TJ564T
RES , CARBON
560K OHM 1/5W J
CRD20TJ473T
RES , CARBON
47K OHM 1/5W J
CRD20TJ751T
RES , CARBON
750 OHM 1/5W J
CRD20TJ471T
RES , CARBON
470 OHM 1/5W J
CRD25TJ101T
CRD20TJ474T
CRD20TJ184T
CRD25TJ471T
CRD20TJ202T
CRD20TJ222T
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
100 OHM 1/4W J
470K OHM 1/5W J
180K OHM 1/5W J
470 OHM 1/4W J
2K OHM 1/5W J
2.2K OHM 1/5W J
CRD20TJ152T
RES , CARBON
1.5K OHM 1/5W J
CRD20TJ562T
CRD20TJ332T
CRD20TJ103T
CRD20TJ822T
CRD20TJ105T
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
5.6K OHM 1/5W J
3.3K OHM 1/5W J
10K OHM 1/5W J
8.2K OHM 1/5W J
1M OHM 1/5W J
CRD20TJ333T
RES , CARBON
33K OHM 1/5W J
REF NO.
R307,308
R309,310
R311~314
R321,322,343,344
R611
R323~334
R335~338
R339~342
R345,346
R347~350,621
R351~354
R357,358
R361,362,609,610
R619,620
R371~374
R381,382
R383
R391~393
R601~604
R607,608
R612,613
R614
R355,356
R375,376
R377,378
R605,606
R615
R427
R413,414
R434
R426,429,430,435
R421,423
▶SEMI RESISTOR
VR31,32
▶WIRE ASS'Y
BN62
BN63
BN64
JW31
JW32
JW33
JW34,35
▶CONNECTOR
CN26
CN31,32
CN61
CN71
CN73,74
CN75
CN81
CN82
CN91
▶I.C
IC11,14,16,21
IC41~43
IC12
IC13
IC15
IC61
IC64
IC65
PCB, MAIN
CUP11654Y
PART NO.
1st DESCRIPTION
CRD20TJ100T
RES , CARBON
CRD20TJ271T
RES , CARBON
CRD20TJ221T
RES , CARBON
HK3380/230
2nd DESCRIPTION
10 OHM 1/5W J
270 OHM 1/5W J
220 OHM 1/5W J
CRD20TJ122T
RES , CARBON
1.2K OHM 1/5W J
CRD20TJ561T
CRD20TJ750T
CRD20TJ223T
CRD20TJ331T
KRD25FJ3R3T
KRD25FJ180T
CRD20TJ511T
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
560 OHM 1/5W J
75 OHM 1/5W J
22K OHM 1/5W J
330 OHM 1/5W J
3.3 OHM 1/4W J
18 OHM 1/4W J
510 OHM 1/5W J
CRD20TJ182T
RES , CARBON
1.8K OHM 1/5W J
CRD25TJ470T
CRD20TJ273T
CRD20TJ433T
CRD20TJ470T
CRD25TJ393T
CRD20TJ123T
CRD20TJ560T
CRD20TJ820T
CRF5EKR22HX2
CRG1ANJ100H
CRG1ANJ221H
KRQ1AJR47H
KRQ1AJ100H
CRD20TJ151T
CRD20TJ220T
CRD20TJ4R7T
CRD20TJ512T
CRD20TJ622T
RES , CARBON
RES , CARBON
RES , CARBON HK 3480 only
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CARBON
RES , CEMENT
RES , METAL OXIDE FILM
RES , METAL OXIDE FILM
RES , FUSE
RES , FUSE
RES , CARBON HK 3480 only
RES , CARBON HK 3480 only
RES , CARBON HK 3480 only
RES , CARBON HK 3480 only
RES , CARBON HK 3480 only
47 OHM 1/4W J
27K OHM 1/5W J
43K OHM 1/5W J
47 OHM 1/5W J
39K OHM 1/4W J
12K OHM 1/5W J
56 OHM 1/5W J
82 OHM 1/5W J
0.22OHM(*2), 5W
10 OHM 1W J
220 OHM 1W J
0.47 OHM 1W J
10 OHM 1W J
150 OHM 1/5W J
22 OHM 1/5W J
4.7 OHM 1/5W J
5.1K OHM J
6.2K OHM 1/5W J
HVN1RA221B01T
RES , SEMI FIXED(220 OHM)
RH0615C100221
CWB4FA32120PU
CWB3FE03280UP
CWB1C906200BM
CWE7202050AA
CWE7202070AA
CWE7202060AA
CWE7202090AA
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
WIRE ASS'Y
CJP13GA115ZY
KJP02GA01ZM
KJP02KA060ZY
KJP12GA19ZM
KJP03GA19ZM
KJP02GA19ZM
CJP20GA147ZW
KJP07GA19ZM
KJP09GA19ZM
WAFER , CARD CABLE
WAFER
WAFER
WAFER
WAFER
WAFER
20 DUAL WAFER
WAFER
WAFER
HVINJM2068MDTE1
HVITC9164AF
HVITC9163AF
HVITC9459F
HVIL7805CP
CVIL7815CPVA
CVIL7915CPVA
I.C , OP AMP
I.C , FUNCTION
I.C , FUNCTION
I.C , VOLUME
I.C, REGULATOR
I.C ASS'Y
I.C ASS'Y
MOLEX 5267-02A
7.92MM(YUNHO)
JWT
MOLEX53014-0710
MOLEX53014-0910
NJM2068MD-TE1
TC9164AF
TC9163AF
REF NO.
▶JACK
JK10
JK11,12
JK13
JK14
JK15
▶COIL
L301,302
▶OUTLET
OL61
▶RELAY
RY31,32
RY61
▶POSISTOR
TH31
▶SUB TRANS
T602
▶CARD CABLE
BN26
▶FUSE
F601
F601
F602
F603,604
F603,604
▶OTHERS
T601
PCB, MAIN
PART NO.
CUP11654Y
1st DESCRIPTION
HK3380/230
2nd DESCRIPTION
CJJ4N060Z
CJJ4P014W
CJJ4R019W
CJJ4R021W
CJJ5Q006Z
JACK , BOARD 2P (GOLD)
JACK , IN/OUT
TERMINAL , IN/OUT
JACK , IN/OUT
TERMINAL , SPEAKER
CLEY0R5KAK
COIL , SPEAKER
0.5UH
KJJ7A025Z
OUTLET , EUR (2P)
A3-04-D007-2P
HSL4A004ZU
HSL1A008ZE
RELAY
RELAY
OSA-SS-212DM3
SDT-S-112DMR
KRTP42T7D330B
THERMAL SENSOR , POSISTOR
P42T7D330BW20
CLT5J033ZE
TRANS , SUB
CWC1C4A13B170B
CARD , CABLE
KBA2C4000TLEY
KBA2C6300TLEY
KBA2D2500TLET
KBA2C6300TLEY
KBA2C8000TLEY
FUSE HK3380/230
FUSE HK3480/230
FUSE
FUSE HK3380/230
FUSE HK 3480/230
CLT5U021ZE
CLT5V036ZE
TRANS , POWER HK3380/230
TRANS , POWER HK3480/230
K
T 4A L 250V
T 6.3A L 250V
T 2.5A L 250V
T 6.3A L 250V
T 8A L 250V
KB1010B
NJM2068
DISPLAY
SAA6579TV1
RE5VL28
SAA6579
2 PIN DESCRIPTION
PE3
PE2
PE1 / RDI
PE0 / TDO
VDD_2
OSC1
OSC2
VSS_2
TLI
EVD
RESET
VPP / ICCSEL
PA7 (HS) / SCLI
PA6 (HS) / SDAI
PA5 (HS)
PA4 (HS)
Figure 2. 64-Pin TQFP 14x14 and 10x10 Package Pinout
AIN2 / PD2
AIN3 / PD3
64
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
63 62 61 60 59 58 57 56 55 54 53 52 51 50 49
48
47
46
45
ei0
44
43
ei2
42
41
40
39
ei3
38
37
36
35
ei1
34
33
18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
VSS_1
VDD_1
PA3 (HS)
PA2
PA1
PA0
PC7 / SS / AIN15
PC6 / SCK / ICCCLK
PC5 / MOSI / AIN14
PC4 / MISO / ICCDATA
PC3 (HS) / ICAP1_B
PC2 (HS) / ICAP2_B
PC1 / OCMP1_B / AIN13
PC0 / OCMP2_B / AIN12
VSS_0
VDD_0
AIN4 / PD4
AIN5 / PD5
AIN6 / PD6
AIN7 / PD7
VAREF
VSSA
VDD_3
VSS_3
MCO / AIN8 / PF0
BEEP / (HS) PF1
(HS) PF2
OCMP2_A / AIN9 / PF3
OCMP1_A / AIN10 / PF4
ICAP2_A / AIN11 / PF5
ICAP1_A / (HS) PF6
EXTCLK_A / (HS) PF7
(HS) PE4
(HS) PE5
(HS) PE6
(HS) PE7
PWM3 / PB0
PWM2 / PB1
PWM1 / PB2
PWM0 /PB3
ARTCLK /(HS) PB4
ARTIC1 / PB5
ARTIC2 / PB6
PB7
AIN0 / PD0
AIN1 / PD1
(HS) 20mA high sink capability
eix associated external interrupt vector
HVIST72F321R (U-COM)
:
IC81
Figure 1. Device Block Diagram
8-BIT CORE
ALU
RESET
VPP
TLI
VSS
VDD
PROGRAM
MEMORY
(16K - 60K Bytes)
CONTROL
RAM
(512 - 2048 Bytes)
LVD
EVD
AVD
OSC1
OSC2
OSC
WATCHDOG
PORT F
PF7:0
(8-bits)
TIMER A
BEEP
ADDRESS AND DATA BUS
MCC/RTC/BEEP
I2C
PORT A
PORT B
PB7:0
(8-bits)
PWM ART
PORT C
PORT E
TIMER B
PE7:0
(8-bits)
PA7:0
(8-bits)
PC7:0
(8-bits)
SCI
SPI
PORT D
PD7:0
(8-bits)
10-BIT ADC
VAREF
VSSA
3
TC9164AF (FUNCTION/INPUT) : IC12
BLOCK DIAGRAM
Vss
GND
VDD
1
14
28
27
R-S 1
L-S 2
3
26
R-S 2
L-S 3
4
25
R-S 3
L-S 4
5
24
R-S 4
L-COM 1
6
23
R-COM1
L-S 5
7
22
R-S5
L-S 6
8
L-COM2
9
LEVEL SHIFTER
LATCH CIRCUIT
LATCH CIRCUIT
2
LEVEL SHIFTER
L-S 1
21 R-S 6
20 R-COM 2
L-S 7 10
19
R-S 7
L-S 8 11
18
R-S 8
L-COM 3 12
17
R-COM3
ST 13
16
DATA
15
CK
SHIFT REGISTER
TC9163AF (FUNCTION/INPUT) : IC13
BLOCK DIAGRAM
Vss
GND
VDD
1
14
28
3
26 R-S 2
L-S 3
4
25 R-S 3
L-COM 1
5
24 R-COM 1
L-S 4
6
L-S 5
7
L-S 6
8
L-COM 2
9
L-S 7
10
19 R-S
7
L-S 8
11
18 R-S
8
L-COM 3
12
17 R-COM 3
13
16 DATA
ST
LEVEL SHIFTER
L-S 2
LATCH CIRCUIT
27
LATCH CIRCUIT
2
LEVEL SHIFTER
L-S 1
R-S 1
23 R-S 4
22 R-S 5
21 R-S 6
20 R-COM 2
SHIFT REGISTER
15 CK