volkswagen - TheSamba.com

Transcription

VOLKSWAGEN
MOOEL IDENTIFICATION
Before making an estimate or ·using any prices listed, it is recommended that the vehicle first
be identified by the chassis number. Then, referring to the chart listed below, find the model
and chassis number.
CHASSIS NUMBER LOCATION
ENGINE NUMBER LOCATIONS
BEETLE. SUPER BEETLE & THING On identification
BEETLE·SUPER
plate and on frame tunnel under rear seat.
BEETLE-GHIA
GHIA-
FASTBACK-SQUARE
On fr.me tunnel under the emergency seat.
FASTBACK-SQUAR
-
On crankcase .t the generator support fl•••.
BACK·
On the cr.nkcase beside the joint nur the oil cooler.
E BACK-
411 (TYPE 4) -
On tr.me tunnel under the rear seat.
On right h.nd cr.nkcase h.1f below the breather support.
& BUSOn the crankcase fl.nge under the generator support.
411 (TYPE 4)-
TRUCK
On identification plate under rear seat betwellfl inner seat belt mountings.
TRUCK & BUSOn engine cover plate under tlhe .ir cleaner.
THING -
DASHER
OASHER-RABBIT-SCIROCCO
-
On cr.nkcase at genetator support flange.
In engine compartment on front partition above windshield wllSher container.
RABBIT & SCIROCCO On the suspension strut mounting .t right front wheelhouse.
VANAGON
VANAGON
JETTA -
-
On plate under vehicle on right side of front crossmember.
-
On left hand side of engine block .bove fuel pump;
-
On right hand crankcase behind fan housing.
On engine block, under glow plug cylinder 3.
JETTA & QUANTUM
In engine compartment
on cowl top panel.
STARTING CHASSIS NUMBERS
BEETLE (TYPE 1).
1968
118000001
1969
119000001
1970
1102000001
1971
1112000001
1972
1122000001
1973
1132000001
1974
1142000001
1975
1152000001
1976
1162000001
1977
1172000001
1978
1182000001
SUPER BEETLE (TYPE 1)
1971
1112000001
1972
1122000001
1973
1332000001
1974
1342000001
1975
1352000001
1976
1562000001
1977
1572000001
1978
1582000001
1979
1592000001
GHIA (TYPE 11
1968
148000001
1969
149000001
1970
1402000001
1971
1412000001
1972
1422000001
1973
1432000001
1974
1442000001
THING
1812000001
1971
1822000001
1972
1832000001
1973
1842000001
1974
1852000001
1975
TRUCK & BUS (TYPE 2)
1968
218000001
1969
219000001
1970
2102000001
1971
2112000001
1972
2122000001
1973
2132000001
1974
2142000001
1975
2152000001
1976
2162000001
1977
2172000001
1978
2182000001
1979
2192000001
FASTBACK·SQUAR EBACK
(TYPE 3)
1968
318000001
1969
319000001
1970
3102000001
1971
3112000001
1972
3122000001
1973
3132000001
411 III 412 (TYPE 41
1969
419000001
1970
4102000001
1971
4112000001
1972
4122000001
1973
4132000001
1974
DASHER
1974
1975
1976
1977
1978
1979
1980
1981
4142000001
3242011947
3252000001
3262000001
3272000001
3282000001
3292000001
32A0000001
328900001
RABB(T
1975
1976
19n
1978
1979
1979
1980
1980
1981
1981
1982
1982
1983
1983
PICK-UP
1980
1981
1982
1983
SCIROCCO
1975
1976
19n
1978
1979
1980
1981
1982
1983
JETTA
1980
1981
1982
1983
VANAGON
1980
1981
1982
1983
QUANTUM
1982
1983
1753025868
1763000001
ln3000001
1783000001
1793000001 (Imported)
1793750050 (Domestic)
15A0800001 (Imported)
17A0750001 (Domestic)
158000001 (Imported)
17B000001 (Domestic)
15COOOOOl (Imported)
17COOO001 (Domestic)
150000001 (Imported)
170000001 (Domestic)
1.7A0705001
178000001
17C000001
170000001
5352000001
5362000001
5372000001
5382000001
5392000001
53A0000001
53BOOOOOl
53C000001
530000001
16A0000001
16BOOOOOl
16C000001
160000001
24A000001
248000001
24C000001
240000001
32COOOOOl
320000001
F21
VOLKSWAGEN
BODY TYPE NUMBER LOCATION
BEETLE & SUPER BEETlEOn a plate on reinforcement panel in front luggage
compartment (behind spare wheel or on front cross
panel for model "1301" & "1303"
411 (TYPE 4) Under front panel beside the hood lock.
GHIA·FASTBACK·NOTCHBACK·SaUAREBACK
On identification plate in front luggage compartment
besides spare wheel.
TRtlCK & BUS On identification plate on partition behind passenger seat.
THING On identification plate under front panel beside hood lock.
DASHER On right hand wheelhouse in the engine compartment.
RABBIT - SCIROCCO - JETTAOn the front lock carrier to right of hood lock.
VANAGON On identification plate on right hand hinge pillar.
BODY TYPES
BEETLE
11'1
113
115
117
151
Standard Sedan
Deluxe Sedan
StandardSedan,
w/sliding Roof
Deluxe Sedan, w/sliding Roof
Convertible
SUPER BEETLE
ToJuly,1972
(1302)113
Deluxe Sedan
117
151
Convertible
From August 1972 (1303) 133
Deluxe Sedan
133
153
Convertible
GHIA
141
143
Convertible
Coupe
TRUCK & BUS
211
215
221
225
231
235
241
251
261
265
281
285
DELIVERY VAN, Sliding Door Right
-Sliding Door Right & left
MICRO-BUS
MICRO-BUS, w/sliding Roof
KOMBI
KOMBI, w/sliding Roof
MICRO-BUS "l"
MICRO-BUS "l" 7 seater
Pick-Up, Single Cab
-Double Cab
MICRO-BUS, 7 Seater
-7 Seater, w/sliding Roof
FASTBACK
311
313
Sedan
Sedan, w/sliding Roof
saUAREBACK
365
367
Variant
Variant, w/sliding Roof
411 & 412
421
461
4-000r Sedan "(,,
2-000r Station Wagon "L" (Variant)
DASHER
321
323
331
2-000r Sedan
4-000r Sedan
Station Wagon
THING
181
4-000r
171
173
175
177
155
179
2-Door
4-000r
2-Door
4-Door
2-Door
Pick·Up
SCIROCCO
531
Coupe
VANAGON
255
Micro-Bus
JETTA
161
163
2-000r Sedan
4- Door Sedan
RABBIT
F22
Sedan (Imported
Sedan (Imported
Sedan (Domestic
Sedan (Domestic
Convertible
Version)
Version)
Version)
Version)
QUANTUM
321
327
331
2-000r
4-000r
4-000r, Square Back
1979-68 VWBUS& TRUCK
Information in the "GUiDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.
9
--------
I
!
FRONT BUMPER·1968·72
Assembly R&I . .. .. . . . .. . . . . . .. . .
0.5
Overhaul
1.1
w/o guards
.
1.3
w/guards
.
Face bar
1 center
(pA)
104.05 0.8
2 side
(pA)
AT 65.60 0.2
(p.4)
LT 65.60 0.2
3 step pad
AT 13.30 0.2
LT 13.30 0.2
4 joint cover (rubber) ..
. 0.00
Guard & cushion.. .. .. .. .. .. ..
08.40 0.2
cushion
D1.85
STrim mldg
68·69 AT 041.70
68·69 LT D41.70
70·72 AT D54.00
70·72 LT 058.00
rubber insert
68·70
D14.00
71·72
014.00
7 Mounting bracket
AT 16.75
LT 16.75
FRONT BUMPER, 197:J.79
Assembly R&I .. .. .. . . . .. . .. .. .. .
0.5
Overhaul.. . . .. .. .. .. .. .. . .. .. . . .
1.5
8 Face bar, prime......
164.95 # 1.5
chrome
461.50 # 1.5
9 Rubbei cush &end caps
. .. .. 71.95
10 end caps
.. .. .. .. .. ..
8.85
11 Deformation element............
186.45 3.0
# Time is for overhaul
10 8
'
2117071118
211707114
211707113 1 Front crossmember
211707292 2 cover plate
211707291 3 Sidemember, outer
211707197
ZVW151812
ZVW151822
inner
2417072128
241707211D
241707212C 5 Rear, assembly
241707211E 6 sidemember, outer
241707221C
bracket
241707221C 7
inner
211707136M 8
211707135E 9 Outrigger, front
1968-71
59.60 # 2.5
33.40
68·89 AT D15O.oof; 10.0
68-69 LT D15O.00# 10.0
70·71 AT 249.15 #10.0
70·71 LT 249.15#10.0
AT DI32.00 § 6.0
LT 0132.00 § 6.0
D471.10
RT 0 88.00 # 8.0
LT D86.00 # 8.0
Dl1.00
D48.00§ 4.0
AT' 65.45
LT 65.45
10
center.. .. .. .. .. .. .. .. . 65.45
11
rear...................
9.20
211707111J12 Cover plate, front........
.. .. 51.90 0.5
22170711113 side, under floor
AT 58.55
241iOi221E
LT
58.55
241707219
1972·79
211707271 1 Front erossmember .... 72
59.60 # 2.5
73·79
96.95 # 3.5
2 cover plate.. .. .. ..
72 .. .. 33.40
3 Sidemember,outer
72·73 RT 249.15#10.0
72·73 LT 249.15 # 10.0
74·79 AT 249.15 # 10.5
74·79 LT 249.15#10.5
4
inner ..... 72 AT 0132.00§ 6.0
72 LT D132.00§ 6.0
73·79 RT 188.90§ 6.0
73·79 LT 188.90§ 6.0
5 Rear assy
72
D471.10
73·76
0584.00
use seperate parts
6 sidemember, outer
RT 129.35# 8.0
LT 129.35 # 8.0
8
inner
RT 68.65
LT 79.30
67.45 t 3.0
crossmember, rear
.
gusset plate
.
9 Outrigger, front
. 65.45
10
center
RT 65.45
65.45
LT
11
rear....
.. . 9.20
12 Cover plate, fronl.
. 51.90 0.5
13 side, under floor. .. .. .. ..
RT 58.55
LT 58.55
# After necessary dismantling.
§ Afteroulerrail
is removed.
t
F412
After aI/ bolted-on parts are removed.
FRONT PANEL & W'SHIELO
Front panel
1 wo/air duct...
(p3.7) 68·72
491.90# 19.5
211805035H
2
(p3.7) 73·79
491.90 # 19.5
211805035J
w/air duct.....
(p3.7).........
726.00 # 19.5
211805031AJ
3 reinf, Iwrto floor
68·72
038.00
2118053310
4
73·79
50.35
211805331F
5 extension .. .. .. .. ... 73·79 RT
5.50
211805268
211805267
73·79 LT
5.50
211703071G 5
cover plate.. .. .. .... 68·72 .... 33.40 0.5
211805257
211805257
lower plate.. .. .. .. .. .. .. .. .. .. 71.50
211805269
2117030228
hinge pillar .... (p1.0) 68-72'.. .. 0142.00 § 9.0
21180920tF
2117030218
(p1.0) 73-79 .... 224.35§ 9.0
211809201E
211703022D
conn piece, upper ..•..........
8.20
211809269
2117030210
lower .... 72
10.15
2118092498
211703304A
73·79
10.15
211809249C
211703303A
37.75 0,2
211853601C
211703051C 8 Emblem, VW, painted .. 68·72
211853601E
73·79
9.55 0.2
211703110A
chrome ... 68-72
031.00 0.2
2418536018
211703109A
73-79
35.10 0.2
241853601E
211703591
68·72
55.25
211259161
211703459 Air intake grille
73-79
38.55
211259163A
211703116
9
trtm
frame
..
".................
61.90
0.5
241853215
211703115
screen
68·79
27.50
21t259165A .
211703119A
211703163 Windshield
glass, VW, Clear .... "..........
169.85t 1.6
211645101K
211703611H
Sunshade ... " .. ... 426.30 t 1.6
221645101
215703706G
NAGS, clear.. .. .. .. .. .. . 220.25t 1.6
FCW201C
215703705G
Sunshade.. .. ..
264.15 t 1.6
FCW201S
rubber chnl
68,]1
57.00
2418451218
211703071G
2116451210
72·79
58.00
2117035610
255853345A
moulding, reveal................
10.05
211805257
joint..................
1.00
315853309
2t1703022D Mirror, inside
211857501A
.. 68·69
61.85 0.2
2117030210
70·71
60.30 0.2 211857501KOOV
211703022E
211857501J
72·79
60.30 0.2
211703021E Wiper arm.. .. .. .. .. ... 68 .. .. 10.95 0.1
211955407C
211703304A
211955409A
69·72
15.00 0.1
2t1703303A
73·79
17.70 0.1
2119554098
211703304C
blade
68 .. .. 13.80 0.1
1479554258
211703303C
161955425
69·72
10.15 0.1
211703051C
176955425A
73·79
5.20 0.1
211703051E
motor.. .. . .. .. .. .. ... 68·72
189.75 1.0
211955113H
73·79
t72.40 1.0
2119551130
211703110D
washer reservoir................
27.60 0.4
2119554538
2117031090
pump..................
33.00
823955651
2t1703460E
INSTRUMENT PANEL
2t1703459E
2117034918 10 Instrument panel
2117036558
padded
211703t15
to 2142164060 ...........•.....
320.85* 3.3
211605045F
211703120A
fm 2146164060
320.85* 3.3 2118050458041
211703119A unpadded
261805051G
211703t63
102142164060
0135.00i 2.1
211805051AP
2117036tlH
fm2142164060 .......•........
146.70* 2.1
215703706G
padded strip...................
120.20 1.1 2118572058041
215703705(3
grab handle.. .. .. .. .. .. .. . .. .. . 12.00 0,3 2118576438041
211805155D
11 plate, top cover.. .. .. .. .. . .. .... 108.95* 1.6
Glove box door.. .. .. .. .. .. .. . .. . 63.85
221857121A041
CONTINUED
The times listed are based on new, undamaged O.E.M.parts installed on new undamaged vehicles
as an individual operation. Add for alignment pulls and refinishing as required.
1979-68 VWBUS&
I
I
Information In the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.
FRONT STRUCTURAL COMPONENTS,
GLASS & LAMPS (CONT)
HEAOLAMP
Aim headlamps ... ..............
Assy, woldoor & seal beam
68·73 RT 049.55
68·73 LT 049.55
order component parts
. ...... RT 38.10
Mtg ring & hsg .
LT 50.55
Door, chrome ...............
RT 22.50
LT 24.55
silver ..........•.......
RT 22.50
LT 24.55
Seal beam .......................
12.30
retaining ring
21.50
chrome ........................
silver
to 2172100001 ................
14.30
fm 2172100001 ...............
14.15
0.2
211941042
211941041
0.4
0.4
321941045
111941045
211941176C
211941175C
211941176C
0.1
0.1
0.1
0.1
0.2
211941175C
N0176152
321941049
111941049
111941049A
PARKING LAMP
Body ..................
68 AT 012.00
68 LT 012.00
69·72 RT 21.80
69·72 LT 21.80
73·79 .... 58.75
68·71 RT 37.75
68·71 LT 37.75
72 RT 31.65
72 LT 31.65
73·79 .... 15.85
68·72 ....
4.85
3.40
73·79 ....
68·72 ....
1.10
1.35
73·77 ....
Lens ..................
gasket. .....•••......
Bulb .. , ...............
211953052E
211953051E
211953052K
211953051K
2119531830
211953142J
211953141J
211953142P
211953141P
211953141T
211953165C
211953165D
N0177382
N0177322
0.2
0.2
0.2
0.2
0.2
0.1
0.1
0.1
0.1
0.1
# Cut in w'shld opng or below opening t5.5. Refinish 3.0.
§ After front panel is removed 4.0.
t With reveal mldgs, add.2.
* With air cond add .8.
AIR CONQITI.O~~R ~ HEATER
With any operation requiring a coolant line disconnect, add .9 to
recharge system & add for freon.
AiR CONO-1968-69
Condenser,
early
late
hsg. upr, early
late
Iwr, early
late
scoop
motor, early
late
mount, ear~
lale
fan, early
late
screen, early
late
Receiver & dehydrator
Compressor
clutch & pulley
68·69
069.30 0.7
69
0126.45 0.7
68-69
016.15
69 .. .. 0.00
68·69
D29.35
69 . . . . 0.00
042.60
68·69
40.80 0.3
69
014.70 0.3
68·69
D 1.95
69 . . .. 02.00
68·69
D2.55 0.3
69 .. . . D .00 0.3
68·69
D2.05
69 . . . . D .00
011.70 0.4
Dl00.55 0.8
68
063.00 0.4
69
Dl10.00 0.4
pulley only
D21.20
coil
D22.25
mounting brkt.
68
D 13.30
69
D13.25
brace, side.. .... .. .. 68
07.50
69
D8.00
front.
69
D4.15
Pulley, driving
"
010.60 0.5
idler
68
D 12.90 0.3
bracket
09.30
support
D6.85
Belt.. .. . .. .. .. .. . .. •. . .. .. . . .. .. 17.40 0.3
Hose
comp to cond
D45.00
comp to evap
046.00
cond to dehyd
68
. " D 12.00
69
D .00
dehyd to evap
68
015.00
I
TRUCK
ZWl217310
ZWl217312
ZWl217307
ZWl217317
ZVW217305
ZWl217318
ZVW217308
ZWl225318
ZWl217324
ZWl217320
ZWl217313
ZWl217322
ZWl217309
ZWl217323
ZWl217316
ZWl217433
ZWl217102
ZWl215130
ZWl217130
ZWl217132
ZVW215131
ZWl217202
ZWl217212
ZWl217207
ZWl215201
ZWl215202
ZWl215229
ZWl215235
ZWl217208
ZWl217209
ZWl217221
ZWl217402
ZWl217412
ZWl217404
ZWl217405
ZWl217408
69
tube
68
Evaporator core
motor
fan, wheel
Valve
expansion
camp, high press.. .. .. .. .. .. . .. .
low press. . . . . .. .. . . . .. . . .
D28.00
Dl.40
D 75.40
D 15.65
D 3.75
0.8
1.1
29.75
9.55
10.60
ZWl217403
ZWl217406
ZWl217006
ZWl217020
ZWl217018
0.5
ZWl231057
059260865
059260855
0.1
ZWl227310
ZWl227304
ZWl227318
ZWl227320
ZWl216312
ZWl227325
ZVW227329
AIRCONO-197o-?3
TOSER
NUMBER 22-301707
Condenser
0147.80
hsg, upper
D49.70
motor .. . .. .. . . . .. .. .. .. •• •. .. . 53.85
mount .............•....
01.50
fan blade .. . .. .. .. .. .. .. . .. . . ..
8.70
screen, front .........•.........
D 37.90
rear ............•.......
D 13.60
Receiver·dehyd
31.10
31.10
0.3
0.3
0.4
0.4
Compressor. .. .. . . .. . .. . . . . . .. .. 303.45 0.8
clutch & pulley
D63.00 0.4
pulley only . .. . .. .. .. .. .. .. . . .. . 88.80
coil
D22.25
mounting brkt...
70
D 13.25
71
D 16.80
72·73
D 45.00
brkt, side
70 .. .. 08.00
71
D 10.05
72-73
014.15
front
70
D4.15
71
9.75
Pulley, driving
70·71
D 11.85 0.5
72·73
21.40 0.5
belt
70
D 16.10 0.3
71
20.10 0.3
72·73
18.55 0.3
Hose, comp to cond .... 70
036.00
71
D 28.00
72-73
D30.00
comp to evap
70
067.00
71
D50.00
72-73
D55.00
-cond to dehyd
71·72
D .00
72·73
0.00
dehyd to evap
D27.00
Evaporator core
70·71
D126.45 0.8
motor
D35.70 1.1
fan. wheel ..................•..
D25.60
Valve, expansion
. . . . . . . 34.25 0.5
comp, high pressure
9.55
low pressure....
10.60
6.70
D3.45
10.75
D9.65
10.20
61.65
distributor ......................
elbow ...............
68·75 .... 21.25
13.75
76
front ..........................
25.15
center .........................
39.60
rear ..............
'" 68-72 .... D21.00
73·79 .... 29.20
vent, upper .....•.....
73·74 ....
68
69·72 RT
69·72 LT
73·74 ....
2112554778
211255475
211255476A
211255475A
2112554758
221255881D
2112558058
211255805C
2112558158
2112558258
221255795
211255795
62-66-688.H.P.
SEE PREVIOUS SECTION EXC
Heat exchanger
62 & 66 BHP . . . . .. . . .. . . . ... 260.20
68 bhp .....................
260.20
conn pipe, hot air ...........
RT 20.15
LT 19.35
elbow .....................
AT 24.95
LT 24.95
heat control box ............
AT 55.05
LT 55.05
warm air hose ......•.•..•......
39.00
bracket, rear ...............
AT
8.90
LT
1.60
059260805
ZWl215130
ZWl218132
ZWl215131
ZWl217212
ZWl232200
ZWl234239
70BHP
ZWl215201 Models wol catalyst
ZWl232212
heat exchanger ....... 68·74 ....
ZWl402225
75 ....
ZWl215202
control box ................
AT
ZWl424213
LT
ZWl225202
elbow, front ....................
255272807
conn pipe to fan ...... 68·74 ....
ZWl227221
75·77 ....
ZWl232221
flex hose ......................
ZWl219222 Models wlcalalyst
ZVW227402 heat exchanger. .. .. .. .. .. . .. ....
ZWl232402
pipe, exhaust. . . . . . . . . . . . . . • . . ..
ZWl219400
afterburner. . . . . . . . •• . •. . ..
ZWl227412
control box ....................
ZWl232412
elbow, front ..........•.........
ZWl219415
conn pipe 10 fan .....•..........
ZWl227411
flex hose ......................
ZWl252406
ZWl227408
ZWl227010
ZWl227020
ZWl227018
803260109
059260865
059260855
1.5
1.5
0.6
0.6
0.6
0.6
021256091M
021256091J
021256332A
021256331A
0212560528
0212560518
021256206K
021256205K
211255387
021256304A
0212563038
260.20
260.20
55.05
55.05
39.60
20.15
20.15
39.00
021256091M
021256091T
021256206K
021256205K
021256051C
021256332A
0212583328
211255387
260.20
220.55
197.00
55.05
39.60
20.15
39.00
021256091T
021251551
021251201
021256205K
021256051C
0212583328
211255387
AIR COND-1973·79, FROM SERIAL
NUMBER22-301707
SEE PREVIOUS SECTION EXC
Condenser,
front. . . .. .. .. . .. .. ..
76·79
rear
76-79
housing, upper, rear
motor. each.. .. .. .. . .. .. .. .. .. .
mount .. .. .. .. .. . .. .
fan blade, each. . . .. . . . . . . .. . . . .
screen, front
rear
Receiver & dehydrator...........
52.60
106.80
68.10
115.35
D22.50
53:85
8.80
8.70
D 28.60
D40.10
31.10
ZWl432336
ZWl432310
ZWl402302
ZWl227318
ZWl402324
ZWl218312
ZWl402332
ZWl402311
0.4
HEATER
44-47-508.H.P.
Heat exchanger.................
hose, to fan housing
warm air, front. .. .. .. .. .. ..
Pipes, rear section
fork piece
68·72
73·79
rear of fork
68·71 AT
68·71 LT
front of fork
68-72
73·79
Pipes, front section
warm air cond
68 .
69·72
130.00
6.00
39.00
1.5
043255106F
028129087A
211255387
24.55
57.00
D 19.55
D19.55
17.30
56.20
211255755F
211255766F
211255765F
211255785A
211255785F
D 2.20
20.75
211255477
211255477A
211255755C
The times listed are based on new, undamaged O.E.M. parts Installed on new undamaged vehicles
F413
I
1979-68 VWBUS&
TRUCK
Information in the "GUIDE TO ESTIMATING" pages must be used with the text below to prepare a complete estimate.
glass, wio healed
CAB ASSEMBLY
wlheated
weatherstrip "'"''''''''''''
~
046.00
217.25
34.30
1.2
1.2
II After roof panel is removed.
§ Withhinge or lock pillar removed 3.5.
t After side panel/s removed 2.5.
After outer panel/s removed.
~
2618455010
261845495C
261845521A
*
FRONTDQOR
VAN
Rails
1 front, above w'shld.. . . . .. .. .. . .. 29.15 # 1.8
2 side, above door
RT 65.80# 2.0
LT 65.80 # 2.0
3 Rocker panel...
(p1.0) 66·71 RT 184.50§ 5.0
(p1.0) 66·71 LT 164.50§ 5.0
(p1.0) 72 RT 221.05 § 5.0
(p1.0) 72 LT 221.05§ 5.0
(p1.0) 73·79 RT 221.05§ 5.0
(p1.0) 73·79 LT 221.05§ 5.0
4Lockpillar
RT 164.60t 5.5
LT 164.60t 5.5
5 Wheelhouse
68·71 RT D45.00* 3.5
68·71 LT D32.75* 3.5
72-79 RT 80.70* 3.5
72·79 LT 80.70* 3.5
PICK-Up, SEE VAN, EXC
Rails, side above door
6 single cab
AT 59.55 # 2.0
LT 59.55# 2.0
double cab, front .. .. .. .. ... AT 65.80 # 2.0
LT 65.80 # 2.0
rear
. 28.35
Lock pillar
7 single cab.. ... (p1.0)
RT 172.80t 5.0
(p1.0)
LT 172.80t 5.0
8 . double cab....
(p1.0)
AT 172.80t 5.0
(p1.0)
LT 164.60t 5.0
9 Corner pnl, otr.. (p2.8)
RT 324.05 11.0
10
(p1.5)
LT 381.40 14.0
11
inr
RT 20.05
12
LT 68.05
13Sill, below pnl
25.85
Back panel
4 upper.........
(p1.0)
12280
5 center
68-71
D74.00
72-79
037.50
6 lower
0121.15
7 x-mbr btwn upr & ctr
25.65
F414
SINGLE CAB
Assembly R & I
. .. . .. .. ..
0.8
Door w/hinges.
(p2.5).........
469.35 # 3.0
W'strip around door ... . . . . . . . . . . 63.45 0.3
Moulding
side front
(d.2)
05.00 0.2
rear
(d.1)
010.00 0.1
window reveal
68·73
61.60
74·77
61.60
Mirror, outside, std
20.85 0.2
pick·up, long top. . . . . . . . . . . . . .
0.3
Glass, clear .. .. .. .. .. .. .. .. .. .. . 60.55 1.2
tinted
68·79
100.80 1.2
sash channel.. .. . .. .. .. . .. . . .. . 5.15
regulator........
45.15 0.7
Ventframe & w'strip . .. .
116.00
glass w/channel & handle
clear
112.15
tinted
150.70
glass only, clear.. .. .. .. .. .. .. .. 32.60 0.8
tinted.. .. . .. .. .. .. .. . 46.05 0.8
Handle w/cyl & keys ... 68
76.95 0.5
69·77
69.25 0.5
Lock..
68
D27.00 1.4
69·73
36.30 1.4
74-77
36.30 1.4
striker.........................
9.10 0.3
cylinder & keys . . . . . .. 68
26.80 0.6
69·77 .... 25.55 0.6
Hinge, cab half
to 2152153713
. 21.35
14.70
fm 2152153713 ........•.....
1m2162126632
. 13.90
Check strap
. 30.40 0.5
211805283A Reflector
to 2162090464 .. .. .. .. .. 10.90 0.1
211817518D
fm 2162090464
10.90 0.1
2118175170
seal...........................
7.75
2118095028
DOUBLECAB
2118095018
211809502C Rear door
(p2.5).........
385.55 # 2.2
211809501C wI hinge
.. .... 45.15 0.7
211809502D W'strip around door.......
lower, on body.. .. .. .. .. .. 23.40 0.7
2118095010
241809252 Stationary glass
rear
68·71
24.75 0.8
241809251
72·79
49.05 0.8
211801326L
w'strip
D15.00
211801325L
87.55 1.2
21t801326P Vent assembly
glass only, clear.. .. .. .. .. .. .. .. 17.45 0.3
211801325P
tinted.. .. .. .. .. .. • .. . 25.55 0.3
weatherstrip
45.85
see cab door
2618175188. Handle,
Lock
68
D20.60 0.4
2618175178
69·79
41.10 0.4
211817518D
striker......................
9.10
211817517D
Check strap.. .. .. .. .. .. .. .. .. .. . 7.60 0.2
2658175360
Front, reflector
261809252G
68, see side assy
261809251FII pa;;;t;;~
inner & outer.
265809252'
265809251
SI;AT TRACKS
26580907481-'-------=--"---'--'--"'------1
265809073C Seattrack
265809944
outer
68·76
D 17.00
265809405A
77
10.00
265809585C
inner
~~'76
~~.~~
2t1831056
2118317210
2418535118
2m~;~~~
241853515
211857513H
261851513A
2116452018
221845201A
211837571A
211637501
241637403
2119030310V
043903109
211903109
111903137D
113101211G
113903803E
211903803E
021903023FV
021903023EV
022903109A
022903109
021903137A
043903803B
111905205AA
211905205Q
021905205Q
021905205E
0219052058
113905207C
111905207C
211837601A
043905115C
221837601A
043905115C
211845251D
221845251
111905865F
21183720SJ
111905865L
211837205N
211905853A
211837015E
211905855C
211837015G
211837015H
211837295D
1119511138
211837217F
211837217HI--,-_W..:,:
. ..:..H::..::.E=E=L=S...::&=-F:....:R:..:.O.::..:...:N..:..T-=S:.:::U:.:::S=-P-=E::..::N:.:::S..:.::'O~~
2tl83t40SA
2116314058
281831405
211837249A
1
~
255841082K
265841818A
265841819A
2
~\
9-1
8
3 -4 ~
18
6 5;~ ". ~~~~__ ~_~~
211945119A
2119451198 ~e ••.•
211945161
11 •
19 ~
_~~~
"1r\:'.'
\~~
17
16
2658453018
265845315A
265645321
224847632
2218452918
221845291A
265847673A
265641606
265841606A
2118372968
265841387
Wheel alignment
Toe·in, adjust. . .. . . .
Suspension, overhaul.
1:~~,
26180542101------E-L-e-C-T-R.. -·;C-A-·L------1
2618054318
261805431C
GENERA TOR& REGULA TOR
261801OB1H Generator assembly
261805441C to eng 91037106
1.0
1.0
1meng 81037106
.
pulley
,
15.65 0.3
toeng81037106 "".""."".
1meng 81037106
. 38.75 0.3
belt
. 2.85 0.3
115.45
support ...............•.........
Voltage regulator
to eng 81037106
24.95 0.4
1meng 81037106................
27.05 0.4
ALTERNATOR & REGULATOR
Alternator assy'
55 amp..
1.0
70 amp...........
1.0
pulley,55ampalt
23.20 0.3
70 amp alt . .. .. . .. .. .. . .. 45.20 0.3
belt.........
5.70 0.3
Voltage regulator.... . .. ..
41.90 0.4
DISTRIBUTOR s IGNITION
Dist assy, 4447 BHP........
..
225.80 0.4
50 BHP
D208.00 0.4
62 BHP
..•..
283.65 0.4
66 BHP
313.60 0.4
68, 10 8HP .. .. .. .. ..
261.95 0.4
cap, exe .. . .. .. .. .. .. .. .. .. .. .. 7.15
4447 8HP
5.15
Ignition coil
wlo emission control.. . ......•.. . 23.10 1.4
wlemission control......
....•...
23.10 1.4
switch only
102142164060
. 19.00
1m2142164060
. 21.25
cylinder & key
68·70 . 25.45 0.5
71-79 . 23.25 0.5
HORN
Horn............................
10.55 0.3
Wheel
2118013438
211B01345E
Hub cap
m~~\~!~~
T'
chrome
. . .. . . .
.. .. .. . .
WHEELS
(p.5) 68·70
(p.5) 71·79
68·70
71.79
68·70
71·79
B~:n~~~f;~~i'~i;~~I"""""'"
1 bearing, outer..................
2
inner..
113903031PV
100.65# 0.3
65.80# 0.3
21.65
13.90
34.70
29.20
. 024.00
9.50 § 0.6
14.8O§ 0.6
CONTINUED
The times listed are based on new, undamaged O.E.M. parts installed on new undamaged vehicles
1.0
0.5
7.0
211601027F
211601027H
111601151
251601151
113601151
251601151A
2416011558
211405645D
211405625
1979-68 VWBUS&
TRUCK
WHEELS & FRONT SUSPENSION
(CONT)
------~~:.:..:..:....L----2-11-40-564-1-01
3 oil seal.
..
spacer
4
wlo disc brake...........
5
wI disc brake.............
6 greaseeap
8.30
06.30
18.40
3.80
FRONTSUSPENSION
DRUM BRAKE
7 Hub & drum
Brakesupportplate
hose..........................
8 Steering knuckle & arm
9 ball·joint,48.3mm
48.6 mm
10 Torsion bar (spring)
arm & ball·joint
11 upper
.
12 lower
13A I b
6869
x e eam.............
.
0213.00
0.8
1.3
37.10 0.8
0177.00 1.4
36.60
0.8
88.75 0.8
273.10
2.7
161.60
RT
LT
RT
LT
70·79
14Shock,standard
786.00*
68·69
70·79....
68·69
heavy duty
· t bl
a dJUsa e............
15 Stabilizer bar........
279.25
279.25
332.20
260.45
78600.
. +.
48.40
55.40
84.10
~g~ 1~!'~~.
.. .. ..
94.40
0.8
0.8
0.8
0.8
25
2.5
0.4
0.4
0.4
~.:
.
0.6
FRONTSUSPEN5/0N
C!rrD.fJ~'MC '!,R}.fJ'E, sxc
pm"" CA'
121.70
68·72
147.80
73·79
115.90
caliper, wo/pads
71·72 RT 215.30
71·72 LT 215.30
73·79
149.20
Girling
149.20
18 splash shield
RT 20.30
18
LT 20.30
hose..........................
28.90
19 Sirg knuckle & arm ..... 68·72 RT 332.00
68·72 LT 0281.70
73·79 AT 332.00
73·79 LT 332.00
Shock absorber, std
55.40
heavy duty
84.10
adjustable.. . .
174.05
"";c run
16 Hub
17Brakedisc
0.8
0.4
0.4
0.8
0.8
0.8
0.8
0.8
1.4
1.4
1.4
1.4
0.4
0.4
0.4
WAGON& VAN
211415801F
1 Tierodassy
RT 44.50 0.4
.
7.3
211415801F Headlining R & I
2
LT 44.50 0.4
3 end...........................
21.05 0.3
311415811C Roof panel
4 Intermediate arm.... . ..
112.85 1.0
(p5.0)
557.00#21.0
211817111G
2114157410 1 solid roof.....
678.00 28.5
241817111G
5 shaft package.. .. .. . .. .. .. .. .. . 55.25
211498171A 2 slidingroof.. .. (p4.7).........
211405631A 6 Damper.........................
17.90
0.5
211817111K
2264.00
211425021A enlarged (plastic)
2114056318 7 Drag link........................
57.55 0.9
770.00 § 6.0
241817201
211415701G 3 Frame, sliding roof
2114056918 8 Pitman arm
68·72
107.85 0.5
2114153718 rail above slide door
41.35§ 1.8
211809904A
211415371C 4 guide. .. .. ..
73·77
78.90
0.5
211809908A
2114152210 5 channel.. .. .. .. .. .. .. . .. .. . .. . 7.20
9 shaft & eam
68·69 0139.00
2118175370
R&L 35.95§ 3.5
211405615C
70·72
185.55
211415221F 6 above body side
7 rear.. . .. .. .. .. .. .. .. .. .. .. .. .. 44.50§ 2.3
211817565G
211609139C
use gear assembly
73·79
211817569
211415205F 8
cover plate
68·70
017.50
21161170310 worm
68·72
265.95
70·77
28.60
2118175698
211405311C
use gear assembly
73·79
211405371A11 Gearassembly
68·72
588.00# 1.7
211415049F
SLIDING ROOF SECTION (FIG K)
211405373
73·79
588.00# 1.7
211415049H 9 Sliding panel
464.30 0.7
24t877071
211411033E12 housing,useassy...............
§ 3.5
10 Weatherstrip. . .. . . . . ..
. . . . 72.35 0.5
241877223
13
end cover
68·72
032.00
211415131811 Frame..........................
92.10
241877259
211405102A
STEERINGCOLUM&
WHEEL
12Lining
67.50 0.8 241877505A581
211405101814 Main shaft
241877355
13 Guide rail, side
R&L 91.50
211405152 to 2142164060
6874
12635 07
211415501A Cable channel
21140511E
.
.
.
211415501C14 upper center.. .. ..
.. .. .. 3.00
241877361
211401061K fm2142164060
72·74
120.55 0.7
211401061N15 coupling disc...................
11.65
313877366A
21141541715 side ..............•........
RT
3.75
241877365
21141540916
LT
6.70
211413031F16 flange,.lower
53.20
211413031P17 Column Jacket
68·69
038.00 1.3
241877364
21141556117 lower
RT 54.30
241877363
211413031G
70·71
042.75 1.3
211415561A18
LT 41.55
211413031R
102142164060
72.74
57.65 1.3
241877523
211415561C19 Rain gutter......................
18.60
241877415A
21141545120 Gasket, front....................
12.00
211413035
fm 2142164060
74·79
54.05
211411309A18 brkt, at inst panel
015.00
241877306
211415601F21 Guide, w/cable
RT 51.80
19 cap, lower.... ..
. 6.90
241877305
211415621
LT 48.60
241877369
211415651022 housing, front..................
13.40
0.6
20 Wheel, to 2142164060 .....•......
153.25 0.4
241877375
cover.................
4.75
fm 2142164060
160.30 0.4 211415651G04323
. # With air cond, add.7.
241877481
24 GUide, front .........•.......
R&L 3.90
211405579§ Time is faroverhaul. Withalrcand,add:7.
241877541
25
rear.................
4.45
211615301A...
",.'
'-015."'" '. c· .,
241877403
26 Winding gear.. .. .. .. .. .. . .. .. .. . 32.55 0.4
2116153018.'
.... :l.:- RQ q. ::~."
161877453
27 Handle.. . .. .. .. .. .. .. .. .. .... .... 7.40 0.2
211615108
PICK·UP
211615107
28 Roof panel
2116151078
261817111G
wlo double cab. (p2.8)
416.25 13.0
2116151078
265817111G
wldouble cab..
(p3.3).........
693.00 16.0
211405593
29 Rail, above back panel. . . . . . . . . . . 27.80 § 2.0
261817575C
211405593
# Station wagon 27.5
2816117758
§ Afterroof panel is removed.
211405312E
211405311E
BODY SIDE PANELS
211405312F
211405311F
~.~.' 3" .
211413031P
211413031R
211413035
..
# Add for balance, weights 4 valve stem.
§ TIme is far ane, both.8.
Time Is to R 41 tube assy. to overhaul, add 4.5.
*
"STEERING
5
5"'
~
~...
11 ---....~
',<'.'
.
-17
-
6
2
"V-
,
23
•
~1-10-.
9
~
•
'"
~<Q>
~~
13
~
19
fl-12
14
I~Y
~f
~
1'~
.p
11
Side panel, outer
front
bus & truck .. (p3.0) . .... LT 367.75
1
van
(p2.8) .
2
386.25
rear
bus &truck .. (p3.0) 68·70 .... 0411.35
(p3.0) 71 .... 0469.00
(p3.0) 72·76 .... 702.00
(p3.0) 77-79 .... 670.00
van ........
(p2.8) 68·70 .... 0439.00
(p2.8) 71 .... 0525.00
(p2.8) 72·79 .... 702.00
rear
bus & truck .. (p3.0) 68·70 .... 670.00
19.0
17.5
231809151
211809151
22.0
22.0
22.0
241809164
241809164A
211809164G
221809164A
211809164
211809164C
211809164G
22.0
20.0 .
20.0
20.0
19.0
241809163
CONTINUED
as an lridlvldual operation. Add for alignment pulls and refinishing as required.
F415
I
BODY
SIDE
PANELS
(CONT)
(p3.0) 71-79
670.00
van
(p2.8) 68-79
613.00
Iwrsection....
(p1.6) 68-70 RT D181.75
(p1.6) 68-70 LT D181.75
(p1.6) 71-79 RT 270.45
5 Inner, wndo opng
RT 71.50
6
LT 162.20
Mldg, front..
(d.2)
LT D 14.00
rear
R&LD17.00
on cab lock pillar......
D2.00
Rellector,front..
Dl1.00
rear
D12.00
seal.
D1.50
Door, gas filler
68·71
D 15.00
72.79....
20.05
Cover,slidingdrchnl
LT 65.10
rubber bead......
..
2.50
clamp strip. ... . . . . . . . .. . .
D6.00
7 Lower runner
slidingdoor.....................
78.80I
8 Sill panel
below slidingdoor....
20.30
9
below Ir side pnl
LT 21.35
10Wheelhouse,rear
~~-70 ::::
19.0
18.0
0.2
0.2
0.2
0.1
0.1
0.2
0.2
0.7
2.3
Moulding, reveal
22t809163
front, w/vent, front..............
01.40
211809163C
rear
D9.00
22480917BE
corner............
. D.80
224809177E
wolvent,
D6.00
221809180
joint..............
1.00
221809406C rear, w/vent, front..............
D 1.40
2218094038
rear
D 10.20
241853535
corner.............
D.80
241853537
GLA~ RIGHTSIDE
241853521A
TO Cn 21423()(J(}Q0
211945555 Glass,rear,clear
96.35>
211945557
tinted
144.25>
211945559
weatherstrip
40.80
211829605 Moulding, front..
'" D6.00
211829605C
rear
D8.30
211843797A
jointcover
1.00
281843799
GLAS5.J.RIGHT SIDE
211843818
FROM ,,'H 2152000001
Glass, rear, clear
96.35>
2118016720
tinted
144.25>
weatherstrip
38.60
211809586 Moulding, see to ch 2142300000
211809585C
SIDE MARKER LAMP
r:~~bOdY
14.65
coverp ate
11 Panel, outer
72-79 .... 150.30§ 3.0
dOR~~~PANE1·85
(p2.2) 68-72 RT
(p2.2) 68-72LT
(p2.2) 73-79 RT
(p2.2) 73-79 LT
12 innerupper
68-71 RT
68-71 LT
72-79 AT
72-79 LT
Iwrright .... _.... 68-71 RT
13
180.95t
D145.00t
175.70t
175.70t
D37.00
D37.40
53.40
53.40
D44.90
11.5
11.5
11.5
11.5
~~:~~
~~D~:~
68-71 LT D52.30
72-79 LT 79.85
15 airdellectorplate ..... 68-71
D5.65
14
Engine cover plate
Pillar
16 dooropng .....
72-79
13.90
68-71 RT 26.75
68-71 LT D15.oo
72.79 RT 23.95
72-79 LT 20.05
(p1.0) 68-71
(p1.0) 72-79
071.00> 3.0
91.10> 3.0
Moulding
(d.l)
09.00 0.2
17 Mud flap
68-71
DI9.00 0.2
72-79
30.05 0.2
GLASS,LEFT5IDE
TO CH. 2142300000
Glass, front, clear.........
98.10* 1.1
tinted
128.95* 1.1
w/ventwndo, clear.............
69.25* 1.1
tinted
D81.00* 1.1
Glass, rear, clear................
77.95* 1.1
tinted
089.00* 1.1
W'strip, front....................
46.50* 1.1
rear
030.00 1.1
GLAS5,LEFTSIDE
FROM CH 2152000001
Glass,front,clear
98.10* 1.1
tinted
128.95* 1.1
w/vent,clear
69.25* 1.1
tinted
D81.00* 1.1
Glass, rear, clear....
.. . 77.95 1.1
tinted
D89.00* 1.1
W'strip, front or rear.............
37.15t 1.1
Vent glass & frame, fron~ rear
87.55 0.7
glass only, clear
. 17.45 0.8
tinted
. 25.55 0.8
32.45
weatherstrip ...........•.......
lock arm wi knob
" 14.70
*
*
F416
221801561J
t02162090464..................
11
striker...
8.10
24185333312
handle
69-79
11.90
24185333113 hinge
R&L 12,50
24185334114
weatherstrip.... .. .
1.30
24185334515 spring.........................
10.05
31585330916 SifI,below lid panel. .... .. .... ... 23.30
241853333
DOUBLE CAB
241853353
SE£ SINGLE CAB. EXC
241853341 Outer panel
1 on bed
(p2.0) 68-70 RT D91.00
2
(p2.0) 68-70 LT 0202.00
2218453310
(p2.0) 71-79 RT 288.90
221845331C
(p2.0) 71-79 LT 288.90
244845341B# Aftersidepaneflsremoved.
241853345§ With hinge or/ock pillarremoved 3.5.
241853348t Afterouferpane/isremoved.
3158533091-----------------
1.1
1.1
0.3
2118292218
26f829067A
261829551
261829573
245827401
261809586
12.0
12.0
12.0
12.0
265809044
265809041C
2658090420
265809041H
r
t
2218453310
221845331C
2218453218
1.1
1.1
~~~:~I
~:~g1~~1~1~
I
I
I
211945351A
0.2
11.45
DROPPANELS
211945363A
2618290510
211813363 Im21~~~~~:~:.:::::::::::::::::
11::~
21~~i~~~~ 1 A:~6'd~~~le cab. (p2.6)
651.00# 0.6
265829051C
211813356M# Timeiswithdoorremored.
w/doublecab .. (p2.0)
561.00# 0.6
261829055E
211813355L§ Afterouferpanellsremoved.
2
rear
(pU)
D391.00# 0.5
2618294538
211813344Ct Tlme/sforran,13.0forsw.
3 Hook,front
R&L 46.55 0.2
2618294738
211813343C Wlthchrometrimm/dg.add.2.
rear.......
46.55 0.2
261829447
211813402> Aftercornerpane/Isremoved.
4 eye,side
18.85 0.2
261829445
211813401:,'
.'.. ' .
PICK,.,UP BOX,
5
rear.......................
12.45 0.2
261829361
21181340281":-':':"""-."
-,-'.:..'..:..'---",-_-=--=,::::.~.::!:-:=........:=~:....:.~_~'-'-I6 Hinge,each
18.00 1.0
2118134018
# Painttimeisforinner&outer.
221813240S
~16
1
I-----=S-:::ID:-:E=,":"'L-:::O:-:A:-::D:-:I":"'N:-::G:-D~O~O:-::R-:-----
*
A
~~:~~~~~~
-;~
2218132395
221813239R
211813379
~'t
211813165H
211813162M c-..
211813165N:r
8
~1 7.'
~ 9' 10
,'.
211813421K
211813421P
241853541D
271821811
271821811A Outer panel
1 onbed
..-,
~~-'
.
221111881133136729N8~~.:'1413
~
'. .
,
-'
£
Assembly R&I
Door
bus&truck ....
0.5
D582.00 3.5
728.00 3.5
221843106F
221843106G
wlo ext roof.. (p2.5) 68·73RT 626.00 3.5
van
w/ext roof... (p2.5) 68·73 RT D944.00 3.8
(p2.5) 74-79RT 626.00 3.5
all
(p2.5)
LT 626.00 3.5
Weatherstrip....................
75.40 0.6
Moulding, side
(d.2)
D15.00 0.2
wndoreveal, rear ..... 68-71
D9.00
72-79
D10.20
front..
68-71
Dl.40
72-79....
1.60
corner.............
D.80
261809044
GLASS&HARDEWARE
261809044C Glass, clear....
.. .. . 69.25 0.8
261809041E
tinted
68-79
D81.00 0.8
261809041H rubber channel
D27.00
divisionbar
12.65
261813356M Ventilator frame.................
21.15 0.7
261813355L rubber channel..............
... 32.45
261813356N glass &chennel
261813355N
clear
103.10 0.7
261813344
tinted
_..
124.80 0.7
261813343 glassoniy, clear
17.45 0.8
261813343C
tinted........
.. 25.55 0.8
261813418B arm,w/knob
14.70
221801562N Handle,outside
221801561G w/cyl&key
68-73
60.60 0.2
221801562H wlo cyl&key
74-79.... 28.35 0.2
221801561H cylinder&keys
68-70
26.30 0.3
221801562R
71-73.... 26.30 0.3
2218Of561J
74-79 .... 24.85 0.3
211829605 Lock, front
211829605C
bus &truck.. ..... 68-70
104.15 0.5
261829061E
71-73
104.15 0.5
261829061E
74-79
104.15 0.5
261829571
van
68·70 D113.00 0,5
2618295618'
71-73
164.80 0.5
261829561C
21184310SJ
211843106K
211843106P
214843105E
2118437928
-~.'
(p2.5) 68-73
(p2.S) 74-79
• 3° 4
""-2i;;;i 5~~'
r~!r15
1
12
51NGLECA8
(p2.0) 68-70 RT D55.40
(p2.0) 71·79AT D54.05
(p1.5) 68-70 LT D120.95
(p1.S) 71-79LT 340.85
11.0
10.0
13.0
(p.6) 68-71 RT D138.15
(p.6) 68-71 LT D138.15
68-71RT 0120.00
w/b 68-71 LT Dl00.00
(p.6) 72 AT Dl03.00
(p.6) 72 LT Dl09.00
(p.6) 73-79
144.55
2218453010 4 Pillarengdr
(p.5)
D27.40#
221845301E5 Wheelhouse, rear
68-70 RT D84.00t
2218452810
68-70LT D89.00t
221845281C
71 RT Dl05.00t
2218453330
71 LT D98.00t
221845333C
72·19RT 150.30t
221845321C
.
72-79LT 150.30t
6 Door, gas fdler
68-71
D15.00
224847631
72-77
20.05
22184529187 Lid, fronl.......
(p1.0) 68·76RT 235.75
221845291A
.
(p1.0) 77-79 .... 235.75
221847673A8 weatherstrip...................
46.55
221847681 9
68 .... 66.45
10
69-79 ,... 66.45
6.0
6.0
6.2
6.2
6.0
6.0
6.0
2.0
3.0
3.0
2218453010 2
221845301E3
2218452810 corner
221845281C w/o b'up Imp
2218453330
221845333C w/b'up Impw/b
2418453218
2418453438
..'
.co
13.0
3.0
3.0
3.0
3.0
0.2
0.2
0.7
0.7
0.3
0.3
241853532A
241853331
241853353
241853333
2418533338
241853341
2218452810
221845281C
241845285B
221847659
221847655
221847673A
224847632A
2218476328
2218452916
221845291A
221847682
211843703H
211843703P
2118437090
211843709E
211843710
221843654
2218436548
221843654A
211843654D
211843654F
CONT/NUED
The times fisted are baaed on nl!w, undamaged O.E.M. parts Installed on new undamaged vehicles
as an Individual operation. Add for alignment pulls and refinishing as required.
I
I
74·79
68-70
71-73
74·79
Lock, rear
vanw/extroof
Hold open catch
on door.. . . .. .. .. .. .. .. . . . . . . .. .
on body
.. .. . . . • . . . . .. .. ..
protective plate
front ................••........
rear ................••.........
Hinge, rear ..........••..........
support
to 2 I62030413 .. .. .. .. .. .. .. . ..
fm 2162030413
Roller guide
upper, bus & truck
.
van wi ext rool
.
plastic cover
.
lower.. .. . .. .. .. . 68-79 .
0.5
0.5
0.5
0.5
0.5
211843654J
2118436048
211843604E
2118436040
211843604C
2.70
2.70
190.45 # 0.2
2218436988
2218436988
281843336A
51.70
053.00
57.15
57.15
021.45
48.50
48.50
17.65
0.3
07.50
1.60
0.3
77.80
0.4
!
REA A ~OADING POOR
Assembly R&I
1 Door,
..
.
0.5
wlo
wndws. . . . . .. (p2.5)
w/wndws.
(p2.5)
all.... .... (p2.5)
2 W'strip around door ....
68·71
0338.00 I 1.5
68·71
0230.80 # 2.0
72·79
369.85 # 2.0
68·71
63.25
72-79 ".. 63.25
Moulding, etr
(d.2)
"..
21.95 0.2
window, reveal
R&L 10.05.
joint
" . " .. . ..
1.00
Name plate, volkswagen.. ..... .. 13.35 0.2
2118291050
1.0
1.0
1.0
0.6
0.6
0.3
0.3
" "
see tail lamp
Door............................
Lens .. " ..................•
gasket
"
Bulb
"
68·71
72·79
"".
""
.. "
w/AC .. " .. "
0.4
211829642
0.4
211829641
0.4
0.4
211829642C
211829841C
361827361
331827383
211829332A
211829331A
iF Time lor painting is for inner & outer.
.ENGINE LID
I
0.1
0.1
0.3
0.1
BACK·UP LAMP
Assy
".
031.00
0.2
9.85
11.00
03.05
1.35
0.2
211845501F Body & lens
68·71
17.65
2118454958
72·79 ""
14.90
221845495A Gasket ..........•
" ... 68-71 .... 01.00
241845521E
72·79 .. "
1.70
211829231GI_B-U-lb-. _"_"_"_"_"_,,_,,_,,_,,_,,_,,_,,_,,_._1._70
211829231R
ENGINE
211829211EI--'------=::..=:..:.==-~-----1
211829211H
ENGINE, R & I
2\1~~~~1~
Engine R & I, wlo AC. "
" ..
§ After lid is removed. 80th .6.
Assembly R&I .. . . .. .. .. .. .. . .. ..
1 Lid .... ".......
(p1.3) 68·71
193.40
(p1.3) 72-79
193.40
0.3
0.3
LICENSE LAMP
GLASS & HARDEWARE
Glass, un·healed
68·76
83.05
heated
68·79
213.45
tinted
68·79 ".. 382.30
rubber channel. . . . . . . .. . .. . .. . . 47.35
3 Handle, wlcyl & keys". 68·71 .. " 46.50
72·79 ".. 42.40
4 Lock.. .. " .. " " .. " .. 68·71 .". 23.30
72·79
27.35
striker"
68·71
07.80
72·79 .".
8.65
5 Hinge
" .. 68·71 AT 0 35.65 §
68·71 LT 39.65§
6
72-79 AT 39.65 §
72·79 LT 41.25§
7 slay
"
68·71
19.85
72·79 ""
19.60
8 Torsion bar .... .. .. .. .. .. ... RT 15.05
LT 15.05
2118434368
REAA LAMPS
211843436A~..:.-----....:..!:=..:::..:...:=..:~~--'--~--1
211843486A
TAIL LAMP
211843406E 1968·71
body "" .. " .... " .. 68-69 "" 29.30
70·71 .... 51.45
door
"
68-71 " .. 0 22.70
lens
68·69
19.35
70·71....
37.15
gasket. .... " .. .... 68·69 .. "
5.80
70·71
5.80
bulb, single contact.... 68-71
1.35
double contact. .. 68-71
1.10
1972·79
body
"
". 72·79 "" 49.15
lens
"
72-79
34.30
gasket, to body
72-79
3.15
to lens.. . ..
72·79 .. "
2.05
cap
72·79
13.75
bulb, single contact.... 72·79 .. "
1.35
211829105A
double contact... 72·79 "..
1.10
211829105AK
211829193C
211829193E
241853551C
255853345A
3118533098
311853687
0.5
0.9
0.9
211827025F
211827025K
47,50 BHP.....................
37.70 t 0.8
341101302
62,66 BHP .. . .. .. .. .. . .. . .. .. .. 78.25 t 0.8 021101301AOOl
2118275030
68,70 BHP
211827503L
to GO 0000001 . . .. .. . .. . . 66.40 t 0.8
022101301A
2118132598
70 BHP 1mGO 0000001 .. , ,.. 78.25 t 0.8 039101301COOI
211813259C Crankshaft pulley
261829551
44 BHP.......................
44.15* 0.5
111105251F
211829553
47,50 BHP .. .. ..
.. ..
27.50 * 0.5
113105251G
245827401 Oil cooler
44,47,50 BHP .......•• : ••......
061.45 # 1.0
211827401A
111117021E
62,66,68,70 BHP
154.75 # 1.0
2118132270
02t1170218
211813227H Fan housing
211813175E 44,47,50 BHP . ..
.. 178.50 # 0.7
1131190250
2118132730 62,66,68,70 BHP
464.20 # 0.7
0211191990
211813217C Fan, w/pulley & hub
62,66,68,70 BHP
68·77
200.85 1.0
2118132178
021119031AO
grille, 62,66,68,70..... ..
4.10
02111920701C
Carrier, 44,47 50 BHP
219.70
211199203A
62,66,68,70 BHP
130.95
021199203E
Rubber mount
44,47,50 BHP
68·71 . 13.75* 0.7
211199231A
72·79 . 28.85 * 0.7
211199231C
211945237K
20.20*
0.7
62,66,68,70 BHP
.
021199231C
211945237J
retainer
, .. . ..
R&L 45.90
2111993518
211945117B
support
R&L 35.80
021199221A
211945241G
. 4.95 0.3
021115351A
211945241M Olililler
211945245A Cover plates .
2119452458 44,47,50 BHP
cylinder
RT 24.35 0.2
113119304G
N0177322
2111193038
LT 24.35 0.2
NOI77382
heater channel
lower front.. . .. .. .. .. ..
RT 23.15
043119350B
211945231
rear
RT 23.15
043119352
211945241R
LT . 22.25
043119351B
411941123
air deflector.. .. .. . .. .. .. ... R&L 3.00 0.2
311119317A
411945235
plate
68·71 R&L 6.30
131119357
211945285
72·79
4.60
113119357A
N0177322
crankshaft pulley
68·71
13.75* 0.5
113119533H
N0177382
72-79
13.75i 0.5
113119533L
preheat pipe protect
4.90
2111195n
211941073A
engine, front.. ..•.....
68·71
026.00
2.11119515
211119515A
72·79
50.20
211941375
rear
68·71
29.30 0.7
113119523M
111941371
72-79
60.95 0.7
2111195235
211941361 Cover plates, 62,66,68 70 BHP
N0177322
039119300C
cylinder
68·72 AT 48.05
039119300C
73·79 AT 48.05
all
LT 69.75
021119299M
2119431610
021119358C
warm air duct, Iwr
68·74 RT 23.15 0.2
211943161E
0211193558
68·74 LT 13.60 0.2
211943131C
75-79 RT
6.70 0.2
021119356E
2119431310
75-79 LT 13.60 0.2
021119355E
NO_'7_71_92I front
68·74 RT 22.75
021119362C
68-74 LT 24.30
0211193618
021119362E
75·79 RT 23.15
75·79 LT 08.95
0211193610
021119358
rear.. .. . .. .. .. . .. . .. .... RT 35.95
021119367
LT 54.30
021119320A
deflector plate
RT 11.45
021119319A
LT
9.10
021119513F
engine, Iront
68·72
020.00
021119513P
73·79
41.85
022119513U
043101025
70 BHP
41.85
0211195220
021101025P
rear
AT 12.45
021119527C
92310194101
LT 22.30
021119531
022101025K
center....
12.45
039119227
038101353
exhaust deflector..........
29.15
211903021
BV
043101355H
generator
.
022119281
0211013510
alternalor...
..
.. . .. 9.80
# Time is with engine remo ved. With air cond add t.t.
022101351C§ Withaircondaddf.!.
022101351Ht Att.ercrlmder head IS removed.
022101351Lf Withalfcondadd.5.
21182nl1
21182nl1C
52.35
57.65
iF A Iter door Is removed.
"i..."
I
Engine, overhaul, wlo AC
w/AC
.
.
.
ENGINE PARTS
0.4
0.4
1.3
2.0
12.5
13.6
Crankcase
44,47,50,77 BHP
393.50 # 9.0
62,66,68 BHP
1069.00 # 9.0
70BHP .. ".""
641.00 I 9.0
1meng GO 0027787
1069.00 # 9.0
Cyl head, 44,77 BHP
343.20 § 3.8
50 BHP
"
" . ".. 343.20 § 3.8
62,66 BHP
D291.00 § 3.8
68,70 BHP
to ED 0000640
386.30 § 3.8
fm ED 0000640.. .. ..
386.30 § 3.8
fm GO 0000001
386.30 § 3.8
cover. 44,47,50 BHP
8.15
1131014758
CLUTCH & TRANSMISSION
021101471
62,66,68,70 BHP . . . . . . . . . . . 10.45
CLUTCH
casket
1/ 0.5
.
113101481F Disc, R&I
• 44,47,50 BHP .. ..
.90 0.2
II 1.0
.
021101481 Housing, R&I
62,66.68.10 BHP . .. .. •• .. . 1.60 0.2
retaining spring
TRANSMISSION
043101487 Assembly, R&I
44,47.50 BHP
. 1.60
§ 2.1
.
021101487
62,66,68,70 BHP
. 3.70
78.25
t
0.8
113101311E003
CONTINUED
Cylinder, 44 BHP
.
The times listed .ar~ ~ased on new, undamaged O.E.M. parts installed on new undamaged vehicles
as an indIVIdual operation. Add for alignment pulls and refinishing as required.
F417
I
1979-68 VWBUS&
TRUCK
CLUTCH & TRANSMISSION (CONT)
Case, R&I, exc.... .. .. .. .. .. ..
fromch2000001............
Gearcarrlerassy,R&I............
Gear shift housing, R&I
t
t
t
t
47
4.2
0.3
0.4
iF 17m,Is wIthengln"emoved.
§ IncludesRII,ngln" wlthlllrcond,add.6.
t nm« Is wIthtf/msremaved.
1 drum only
0229063018 2 hub only
022906301C
support plate
0229063010
022129967AC Axle shaft
iF 17m,II lor busaft,r ,ngln, Isremoved.17m,lor truckIs 1.1
3 outer
Air fiow meter
to eng GD 0027786 . .. ....•.....
to eng ED 0000639
fmengGD0027787
Elbow..........................
192.05
282.95
211.35
38.75
Aft",ngln,/sremoyld.
§ 17m,IIwllh,ngln,lnCllr. Wlth,ngln,removed 1.1. Wlthllir
condIIdd.-t.
4'
I
Inner, manua trans
auto trans
5
joint
6 beartng housing
/i',f~f~r!:"C:f{I!Q~bsta~M~.~~~.§)
~~q~.;!:xHl.l1Srs~at~ii;I;i:~,;&;gE~~r
1968·'"
Gasollnetank
68·71
180.001 0.8
72
152.901 0.8
to 2142132408
73·74
160.15# 0.9
fm 2142132408
73·74
180.00# 0.9
fillerneck
68·71
029.00 0.3
72·73
DI27.60 0.3
68·74....
8.65 0.3
Activated carbon contn 68·74....
37.00
mountJng strap
68·74....
8.25
Intake manifold 68·74
47 BHP
68·74
223.55§ 1.7
50 BHP
68·74
227.75§ 1.7
62 BHP
68·74 R&LDI19.75§ 1.7
66SHP
68·74 R&Lo 51.00§ 1.7
68 BHP ,':
68·74 R&L 59.85§ 1.7
Throttleposlboner
68·69 .... D89.00 0.3
70·74 ".. 24.55 0.3
control valve
70·74 " .. D55.00 0.2
high altitude correct
68·74
D12.00
Fuel pump
71·79
71-79
68·70
71·79
144.45
135.40
62.65
55.60
0.3
0.6
1.3
1.3
211809615
211501619
211609439D
211609425L
68·70
71.79
133.60
133.60
20 5
4.4
D396.95
102.45
0120.00
D120.00
141.40
141.40
26.50
0.8
0.8
211501265
211501265C
211501203
211501203A
251598101
211501254
211501253
211501254E
211501253E
251598201
68·70 RT
68·70 LT
71·79 RT
71·79 LT
1968.74
68.71
53.0511.3
72.73
130.30 # 1.3
68.74
240.95 # 1.3
0.5
0.5
1.3
1.3
1.3
1.3
211201075D Muffler,44,47,50BHP
211251051E
211201075H
211251051F
211201075L
62,66,68 BHP
0252510538 7 boot kit........................
211201075M Installation kit
Bearing, rear wheel
211201123A 44,47,SOBHP
68.74....
8.75
2112960098.8 bearing, outer
68-79
49.1010.9
211501283
211201129G Tail pipe
9
iriner
13.60# 0.9
211501287
211201119 44,47,50BHP
68.74....
6.40 0.3
211251237810 oilseal,outr&inr
7.20
211501317
175201601A 62,66 BHP
68.74
49.85 0.3
021251171P11 Radius arm
68·71 RT 289.65 0.7
211501066J
1136091698 68 BHP
68.74....
21.65 0.3
021251185F
68·71 LT D218.00 0.7
211501065J
Damper pipe
72·79 RT 289.65 0.7
211501066K
113129701AB 44,47,50 BHP
68·74....
14.95
147251157
72-79LT 289.65 0.7
211501065K
113129701AP bracket
12 Torsion bar .•..........
68·71 RT 125.85 2.0
211511116A
021129705AD 44,47,50 BHP
68.74
4.85
211251301A
68·71 LT 125.85 2.0
211511115A
021129705L
62,66 BHP
68-74
06.55
0212513018
72·79
125.85 2.0
211511115C
021129705AG
1975-79
13 link plate
68·71
Dl00.00 1.5
2115112058
113131307
M'I Id
7579
9940
021251531
72·79
128.25 1.5
211511205E
113131309A ani 0
.
14
1360
211511225
113131395 Muffler
75·79
126.95
071251053F15
~OV~~..
........•.......
4'20
211511245A
113131401 C~talyst. .:": :
75-79
558.00
043131701E
us Ing....................
.
Installall.on kl~
75-79
7.45
02329805116 Shock absorber
1
slandard
68·71
55.25 0.4
211513031N
44,47,50 BHP
68·74 .". 24.70 0.5
113127025D
cfon~~~~~~gdo~
75.79
268.40
021251501
72·79
63.10 0.4
211513031R
62,66,68 BHP
68·74 ".. 216.25 0.5
021127025A
f 2162070001
7579
17645
021251503A
heavy duty
68·71
82.85 0.4
211513031K
Carburetor, check locally... .....
0.6
m......
.
021251185F
72·79
101.40 0.4
211513033
"
'11
Tall pipe
75-79
21.65
d' t bl
17465 04
211513035
1i75·7"
iF Wlthalrcondadd.-t;
a J~sa e
.
.
GasoJinetank
75·79
180.00# 0.9
211201075M
iF Tlm'lSloroneorboth.
Filler neck
:
75·79 : 24.70
211201119A
;:1. ;~~:,~. ''''. :~": R~FrBUMF,iER;: .1·. ::J!t;,(j<i
cap, w/o lOcking
75·79....
10.30
211201551P AI
35190
021131601 - ,-».~,
=', ~."~ ' .• ,~"'.
I k' ty
75·79
2330
211201551R
r pump.. .. . .. .. .. . .. .. .. .. .. ..
.
AClivat~~~btneco~i~'
75.79 :::: 37:00
175201801A Drlveshaft,w/pulley
114.55
021131681
belt................
.. .
9.65
021131615A
75.79 . .. . 8.25
1138091698 Pressure
mn tg s t rap & brkt . .. .. 75·79
relief valve
5435
021131604
Fuel pump (electric)
148.60
043906091
.
Intake manifold
75·79 R&L 100.35
022133201E :~~~~:~~~~ef~f~~e...
23.40
039131603
Air intake distributor
75·79 .. :. 194.85
022133055J 444750626670BHP
11660
021131617A
Fuel filter
75-79
5.25
133133511 68'BH'P'"
130'55
0211316170
Electronic control unit
. .. . .. .. .. .. . .. .. .. .. .. ..
.
Federal, std trans
Two way valve .. ,..
•... 42.00
171906283
to 2162077584
75
022906021HV
EXHAUSTRECIRCULATIONSYSTEM
2
1m2162077584
75·76
0.00
022906021NV
1975·79
77·79
027909021S Exhaust gas filler
021131617E
w/ocatconverter
75·79
114.00
auto trans
114.00
021131617F
to 2162077584
75
022906021JV w/eat conv .,
pipe, upper
1m2162077584
75·76 .
022906021PV
to eng GD 0011 000 . .. .. .. .. .. . 58.80
022131592C
77·79 .
022906021TV
fm eng GD 0011000
58.80
0221315928
Calif, std trans
D185.90
022906281
to 2162077584
75
022906021LV Valve, reclrculator
decelerator
fm 2162077584
75·76 ....
022906021 QV
10 eng GO 0011000 . . . . . . . . . . 77.85
022133551A
REAR 8l1MPER·1968-72
77-79 " ..
022906021AAVVV
fm eng gd 0011000 .. .. .. .. .. 67.50
022133551C Assembly R&I . . . . . . . . . . . . . .. . . . .
auto trans
0.4
022906021MV Temperature switch
D13.25
022131519 Overhaul.. .. . .. .. .. . .. .. .. .. .. ..
to 2162077584
75
1.1
1 Face bar.......
(p1.O) 68·71 .... 165.75 0.8
211707311F
fm 2162077584
75·76 .
022906021RV ~')'f;· ••roes M-. --• ...,~<~.'·--·uiP~i'-~.~""'''
022906021ABVVV
~/;";';l"<t,~ftEA8i$.I:fD~.8$jg"i.l~·~~~{,f*
77-79 .
(p1.0) 72. .. .. 165.75 0.8
211707311H
harness
Guard, w/cushion
68·72
8.40 0.2
ZVW151812
cushion
68·72
01.85
ZVW151822
to 2162077584
75
456.10
022971761P
2Trlm mldg
68·69
075.00 0.9
241707411C
1m2162077584
75·76
478.05
022971761R
~
12
70·72
107.40 0.9
77-79
456.10
241707411E
022971761A8
~~
13\""
3 rubber insert
68·70
D13.00
2417074218
relay. .
..
. . . .. 81.65
071906059
14
'\
71·72
021.95
241707421C
series resistance
89.00
022906079
4 Mounting brkt
68-71 RT 44.15
211707336A
Fuel injector
55.05
023906031
",~,O
211707335C
68·71 LT 43.90
Pressure regulator
, . . 45.25
022906035
11
Throttle valve
211707336E
72 RT D47.25
2
.-'
housing
0208.00
72 LT 32.60
211707335E
022133062Q
16
3
5 Gravel deflector . . . . . .. 68·72 RT 25.15§ 0.2
211707366D
switch. .. .. .. .. .. .. . .. .. .. ..
D43.00
022906111E
2117073650
68·72 LT 0 22.65§ 0.2
Cold start valve
"...........
40.20
0229061718
6
sealto
bumper..
..
..
..
68·72
....
3.20
2117073978
Auxiliary air reg
65.60
022906045A
Air cleaner
REAR 8UMPER, 197J.79
)liIIC,
022129607M
to eng ED 0025000
0244.00
Assembly R&I . .. . .. . . .. .. .. .. .. .
0.5
to eng GD 0010999
D169.70
022129607S
Overhaul. . . . . . . . . . . . . . . . . .. . . .. .
1.0
1m eng GD 0011000
386.40
022129607L
7 Face bar, prime
73·79
165.75# 1.0
211707311K
1:,'··:&~lln~rQttlY.s1')ll~~;~
c." :
.;;:
.---.
-
••••
~~1 ;.,".~' ,l~.
q~~.
h
~f40
Hub & drum
F418
68·70
213.65
0.4
211501615G
CONTINUED
as an Individual operation. Add for alignment pulls and refinishing as required.
"-'-
1979-68 VW BUS & TRUCK
I
I
NOTES
REAR BUMPER (CONT)
chrome
73·79
461.65 # 1.0
8 Rubber cush & end caps 73·79
81.60
9 endcaps
73·79
B.85
10 Mounting brkl
73·79 AT 44.20
73·79 LT 35.95
11 Cover plate, muffler .... 73·79 .... 16.45 0.2
NOTES
221707311A
241707421D
241707219
211707336C
211707335D
211707399A
If Time is for oyerhsu!.
§ After bumper Is removea
IEA9107
NOTES
I
The times listed are based on new, undamaged O.E.M. parts installed on new undamaged vehicles
F419
I

volkswagen - TheSamba.com

Transcription

Similar documents