November

Volume 24-11
November 2015
etter of the
Newsl
y
l
h
t
Mon
l
ica
f
Of
November 2014
A Time
to
Gather
AND THE COVVC NORTH
Stark Hughes
Hello everyone. It’s been a very good fall season to be able still drive our vintage VW’s. Hopefully
Mother Nature will bless us with more of the same so we won’t have to put our VW’s in winter hibernation any time soon.
As with longstanding tradition November is the month we gather for Thanksgiving to
wsletter of the
Neand
y
l
enjoy
family
friends.
h
ont
Recently several of us were part of an annual gathering by the LEAKOIL folks in northern Ohio
lM on Kelley’s Island. Al, Tom, Joyce, Kathy (and dog Liam), Kristi, and I all started out Friday at noon for
THE COVVC NORTH
our destination. Four busses met atANDKathy
Kerns to head north. As any of you who have ever traveled a
distance in a group of old VW’s know there is always a chance that the inevitable might happen -breakdown on the road, and of course it happened, 4 times before we even were to Bucyrus. Al Moore’s buss’s
biorhythms were really off that day. Every time Al’s bus had an issue we all faithfully pulled over as to
never leave a fellow traveler behind. On the first stop we replaced the fuel pump. That worked for about
5 miles. Second breakdown Al replaced a coil & fuel filters. Five more miles and on the side of the road
again. Hoping 3rd time was a charm Al was on the side of the road again and he replaced the distributer.
With optimism high we all started off with hopes the distributor was the solution. Once again five miles
later we all pulled over with Al’s bus still not running well. One strange thing about the four breakdowns
Both times the pastors came out and offered us water and
memBerwas twice Al broke down in front of a church.
ryan easley
the use of the church facilities for a rest stop. Our hopes for divine intervention did not happen at either
headchurch
into the but
holiday
a few thoughts
come towas
mind.
the season
graciousness
of the pastors
truly appreciated. On the 4th breakdown we all were at
tank of
gas?
Andend
“have
you seen
our
wits’
staring
intothe
thebattery
enginemaintainer?”
compartment of Al’s bus. Al mentioned maybe it’s the carburetor?
nsureCarburetors
that our Westy
has
a goodnot
winter’s
nap andthat
wakes
are
usually
something
we up
travel with. As fate would have it Kathy Kern said Tom
hing about
the
air
cooled
VWs
is
not
having
the
check
coolant
always kept a spare carburetor in the bus and maybe it’s still there. Low and behold there was a carburetor. Al installed it, did some timing and off we went. Other than an occasional backfire from Al’s bus
63 Beetle
at this year’s
show but
I ran
out of days,Kelley’s
Mr. Mur-Island. Tom’s spirit is still with us and even though he
we traveled
flawlessly
to our
destination,
ine I so
carefully
sealed
both ends
of before Iwas
started
workby having a spare carburetor in his bus if ever there was
was
not there
in body,
his presence
shown
master
bought
didn’t install
30+have
yearsbeen
ago was
a cylinder
need forI one.
Thebut
weekend
couldn’t
better. Perfect weather, great people, an outstanding pot
ve owned
the
car
32
years,
it’s
been
in
restoration
for
the
luck feast Saturday night, and the comraderies ofpast
the VW community. It doesn’t get any better than that.
n’t matter.
AtI this
point
wecomparisons
are going to put
bedtofor
see a
lot of
of him
this to
trip
the Pilgrims’. I’m sure they had problems along the way
te. Our
car willas
beaready
activities
andPilgrims’ arrived at their destination the rest was hisbutproject
persevered
groupfortonext
keepyear’s
going.
Once the
zing just
how
much
room
one littlethat
Beetle
takes
up when
it’s
tory
and
we still
celebrate
event
today
as Thanksgiving.
Sunday morning we said our good byes, and
glad to
have the
space
thewould
garage,have
basement,
shed, would not shift into gear once we got to the mainland.
headed
home.
Asinfate
it Ted’sattic,
Vanagon
That’s another story.
successful
show
in theforward
books and
look towards
election
Looking
to seeing
everyone
this of
month
for the
ng. We’ve
beenNovember
fortunate meeting.
to have a board of directors the past
We
d
h
.
ksngs
velrayer
November 11, 2015
Secretrary Ted Chaney
Meeting
Minutes
October 8th 2015
This meeting was held at Tommy’s Pizza in Dublin.
The consensus was that the 2015 Vintage Volksfest was a success. We added at least 15
new members. Attendance at the show was up, and we had over 300 cars register. The
volunteers who worked at the show were thanked with a round of applause.
The following events are coming up (most of which will be over by the time you read this)
Kelley’s Island Campout Oct 9-11
Colo’s Classic car show at the Zoo
Indianapolis Show Oct 17
Marion Tour Oct 24
MAC Tools Show Oct 10
Mark Richmond will be our representative for the Arthritis Show, assisted by Brad Shisler and Bill Blake, there was
a nice article in the last newsletter about 2016 plans for the show.
Elections will be at the November Meeting. We will need candidates to step up to keep the club going.
Kathy Kern asked for advice on the tools that she should have with her when she travels in her camper.
Don Wuertz commented that he received a call prior to our show from someone in Georgia thinking that our
show was being held near Columbus, Georgia
Ron Baker reported that Papa Boo’s, a bar at Buckeye Lake was interested in sponsoring a car show next year.
The January Banquet was discussed. Most people seem happy with the Spaghetti Warehouse, but we keep our
options open for now.
The NorthEnd Wrench, Inc.!
Your Preventative Maintenance Expert!
Offering the Following Services:
•
•
•
•
•
•
•
Brakes
Exhaust
Tune-Ups
Fluid Changes
Air Conditioning
Foreign & Domestic
Vintage Volkswagen & Porsche
Certied
Technicians
MARION ’S OLDEST
IMPORT AUTO REPAIR
Bill Huntsman, Owner
Foreign & Domestic Repair New & Used Foreign Auto Parts
Monday - Friday
7am - 6pm
Monday - Friday
7am - Licensed
6pm
4330 Indianola Ave.
Columbus, OH 43214
4330 Indianola Ave.
Columbus, OH 43214
740.383.1118
614.263.4978
Celebrating 25 Years of Service!
2
Distributor
or
800.686.2250
614.263.4978
624 East Church Street, Marion, Ohio 43302
www.COVVC.org
Volkswagen
TOYS
Volkswagen
Let’s Talk Toys!
Michael Williams
TOYS
Welcome back everyone!!
The toy I’m sharing with each of you this month was produced by an American toy manufacturer who is still
making toys today. I picked this neat little VW toy up last week from a fellow collector in Arizona. I’ve bought other
examples of this toy over the years, but I was shocked to notice a few features on this toy which were different from
other examples. For now, I’ll keep all of you in suspense until later in the article!! This month’s toy is a white colored VW bus manufactured by the Gay Toy Company of Walled Lake, Michigan during the late 1960’s. This plastic toy is based on a 1960’s VW split window panel bus. The toy is 6.5 inches
long with metal axles and black plastic wheels. What makes the
toy I bought so unique is the actual color of the toy and the side
doors. Gay Toy Company never advertised a white VW bus in their
sales pamphlets. A blue camper and a red ambulance are the only
examples ever produced. Also, the side doors on both the blue
and red examples open, while the white example has non-opening
doors. The toy has never been played with, so I wonder if this toy
was some type of prototype which was never mass produced for
some reason.
I would consider this toy to be extremely rare. I’ve spoken to several fellow VW toy collectors and none of
them have ever seen this color. I’ve been told the toy might have been in the private collection of Jerry Jess who lived
in Arizona many years ago. Jerry was known to have many rare and unique VW and Porsche toys in his collection. I’m really excited to have this toy in my collection now. It’s hard to put a value on the toy being this may be the only
one ever produced. Even though I was lucky to find a near mint example, I still hope to find another white version,
or even some details on this unique little VW toy. Until next month… Happy Toy Hunting !! Renew your COVVC Membership!
Please take a few minutes to check the expiration
date on your mailing label. Please note we now
accept membership payments via PayPal!
Renewals can also be mailed to:
COVVC
13671 Wagram Road,
Pickerington, OH 43147
Or see Brenda Easley at our next meeting. Please
include your current address, phone and e-mail so we
can verify that we have your current info on file.
ONLY $20 PER YEAR!
www.COVVC.org
3
Tech Talk
Bruce Amacker
Converting a Single Master Cylinder to Dual Master Cylinder (Part Two) #58
Last month I detailed the installation of a dual master cylinder in a ’57 Beetle oval window.
This installation makes the car much safer due to the fact that you now have two completely separate hydraulic systems, so in the event of a failure you are assured of having two wheels of brakes
instead of the OEM design which leaves you with none.
This month I’ll cover the conversion on my
’66 split bus which I completed a full restoration on. There
are several ways to accomplish this on an early bus, some
of which are to use ’67 bus parts or later Bay window bus
parts. The ‘67 is a one year design because it’s the last year
of the split bus and the first year of the federally mandated
split hydraulic system. The problem with using ’67 parts is
the cost, which was generally prohibitive until recently when
Chinese parts came down in price. Not surprisingly the quality of these Chinese parts may be in question. I ended up using a Napa reman master cylinder with a lifetime guarantee
for $42 with a fluid reservoir bought from the Samba ads.
The unit I used was a 71-78 Bay Bus MC from a power brake
bus. You’d think a manual brake model would be correct, but
the reservoir outlet spacing is incorrect and nobody makes
a reservoir to fit the manual brake MC. What you need is
outlets that are 3.325” apart center to center and .320” in
diameter below the flared end. This is appropriate for a Rabbit/Volvo/Porsche reservoir which you’ll need to source from
a junkyard or off the Samba classifieds, the aftermarket reservoirs I found had too large of spigots on the bodies. These
days the ’67 parts might be a better choice, as the later Bay
Bus master that I used also needs a spacer made to allow
clearance for the reservoir which would otherwise hit on a
frame crossmember.
This spacer can be purchased for about $30-40 or cut from the
appropriate stock which is ½” thick. I had the correct material in my
scrap bin so I quickly cut one to shape. Using either type of master
cylinder requires fabricating a new MC pushrod from a long bolt, be
careful that the thread sizes may differ. Most pushrods and yokes use
an 8x1.25 thread which is standard metric, but one bus pushrod/yoke
I had on hand was 8x1.0 thread which is an unusual thread. In either
case make up a new rod about 3” in length and grind a rounded tip on
it to engage the MC piston.
Once the MC is mounted, adjust the pushrod free play for
5-7mm clearance at the pedal or 1mm at the MC piston. You’ll also
need a stock bus rubber boot to protect the MC from the elements at
the open (piston) end, which is mounted facing forward and would get
exposed to road splash otherwise. This is especially important if you
don’t plan to install the pedal pan, which is a large sheet metal cover
that prevents road splash from hitting the driver’s controls which are
under the floor pan on a bus. On many of these restored buses this
pan is left off as they don’t see much rain or weather, and it also make
CONTINUED ON PAGE 5
4
www.COVVC.org
MARION TOUR
2015
Tech Talk; Continued
from
Page 4
access to components for inspection and repair much simpler. Once the components are
mounted, it’s time to plumb the system. This is quite intuitive, one line to each front wheel
and one line that feeds the rear axle. The remaining port is for the brake light switch. Now it’s
time to bleed the brakes which I’ve covered in a previous tech column in November of last year. I
use an inexpensive vacuum pump bleeding tool to pull the brake fluid and air from the system. Not only does this
work really well, it’s very time effective and fluid effective, which means you don’t waste much fluid. I can fill and
bleed the entire bus using only 2-3 pints of brake fluid.
Don’t put off that dual MC conversion, safety is of the utmost importance when driving your classic VW,
or any car for that matter!
www.COVVC.org
5
Member
Classifieds
For Sale: 1969 Karmann Ghia
Light Blue, Convertible. Automatic Stickshift. Car is in excellent condition, located in Powell.
Asking $19,900. Please contact Don Hunter by email: [email protected]
For Sale: Lot of Vintage VW Parts
Would like to sell as one lot: Garage full of carburetors, coils, lenses for all types of lights,
windows, rims, beauty rings, hub caps, piston rods back seats in mint condition and more.
Call Roy Woodruff @ 419-526-0182.
For Sale: 1978 Beetle
Selling my 1978 VW Convtertible, Appraised value of VW bug is $16500 Asking $11900.00.
Call Bruce @ 740.964.9856
For Sale: 1960 Beetle
Roof rack, Red with only 48k original miles. One family owned since new.
Asking $7900.00.
Call Lonnie @ 614.419.8153
For Sale: 1979 Super Beetle
All original, Excellent Condition car. Black on Black, Convertible. 35,000 Original Miles, car has
never been in rain or even outside of Ohio! Appraised at $13,800, will consider offers.
Contact Charles Mers 614.679.6446 or [email protected].
For Sale: TOYS!!
Selling off my VW Toy Collection, some rare finds. Please Call Mike Fornataro 740.964.4520
For Sale: 1959 Karmann Ghia
Low Light Coupe, unrestored but repaired. Never rusted or wrecked, Approx 40K on newer
engine, new upholstery. Valued at $8300, (negotiable) great car to show and drive.
Contact Don Bowker @ 330.274.8872
For Sale: 1979 Super Beetle Convertible,
Nile River Blue, excellent condition, always garaged, never out in winter, recently detailed,
a joy to drive. Appraised at $16,900,asking $15,000. Please call Marilyn, 614-299-4841.
For Sale: Collectibles
For Sale, VW collection, toys, cd player, framed pictures and much more--Please call Marilyn Allen, 614-299-4841
WANT ED AD S
Wanted: 6-Volt AM radio (working)
for a 1965 Beetle. Contact Ken @ 440.429.5633
Wanted: 1965-67 Split Window Bus
The better the condition, the better the chance
of a sale. Contact Barnett @ 412.965.6450
6
Wanted: Windshields (2)
Need two front for 66 Split Window Bus
Contact Brian @ 937.206.9293
Wanted: Cargo Door
Treasure Chest Door to fit my 1960 Single Cab.
Contact Mike Boyle 740.438.8570
www.COVVC.org
COVV
Suppo C
rts
Garrett’s Automotive Detailing
By appointment only
Mark Garrett
1294 Frisbee Drive
Columbus, OH 43224
614.262.2881
[email protected]
Specializing
in Show Quality Detailing
Information
In the Spring of 1991 our club was
founded by 12 enthusiasts looking
for a way to pool their parts and
resources to maintain their vintage Volkswagen Cars. Now we are
in our 23rd year with over 200 members and the premiere Vintage
Volkswagen club for Central Ohio. We Strive to share knowledge
and resources while having plenty of fun and we welcome everyone
interested in classic air-cooled as well as newer water-cooled VW
products. Annually we host Ohio’s largest Volkswagen Car show
& swapmeet ‘Volksfest’ to benefit kids ‘n camp; an independent
non-profit organization, devoted to the needs of children with cancer.
Zundfolge
Zundfolge (translated ‘firing order’) is published monthly by the
Central Ohio Vintage Volkswagen Club. Its purpose is to keep
us informed and running smoothly, while providing knowledge
and enthusiam into the Classic VW Community. Members are
encouraged to submit articles and photos for the newsletter. Please
contact the Editor for more information.
* Classified and Wanted ads are free for members.
* Submission Deadline is the 15th of every month.
Factory Data
To obtain VW factory information send your serial number to:
Pre 1955:
VW Brezelffenstervereinigung e.v.
Ernst Reter Hagen, Amselweg 4, D
3073 Liebenau, Germany
Post 1955:
Customer Assistance, Volkswagen AG
Postfach, 3180 Wolfsburg 1, Germany
Streetsboro Foreign Auto, LLC
Officers & Staff
Complete Mechanical & Collision Repair
Specializing in Volkswagen, Audi
& select other European Brands
Elmar Kruza
330.626.2456
Fax 330.626.5030
www.streetsboroforeignauto.com
9796 State Route 14 Streetsboro, OH 44241
John V. Doe
Treasurer
Member Name Badges:
Only $6.00
Available with Pin or Magnet Back
Contact Brian Knoll to order.
Board of Directors:
Brenda Agan
Mark Garrett
Stark Hughes
Ryan Easley
Debbie Garrett
Ryan Cisco
Tom Kern
Mike Roecker
Mike Williams
Ted Bailey
Ann Gilman
Secretary
Treasurer
Membership
Historian
Tech Advisor
Tech Advisor
Tech Advisor
Zundfolge Ed.
Web Editor
Ted Chaney
Todd Sichel
Brenda Easley
Kyle Ray
Carl Dewhurst
Bill Huntsman
Jim Meyer
Brian Knoll
Ann Gillman
www.COVVC.org
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
[email protected]
614.323.2593
614.262.2881
614.843.0751
614.570.4179
614.262.2881
740.709.0183
614.876.8902
216.233.4456
937.390.3794
614.771.0358
614.891.3733
tedchaney2wowway.com
[email protected]
[email protected]
[email protected]
Columbus Area
Marion Area
Circleville Area
614.882.5878
614.252.1431
614.309.8177
614.332.2527
614.830.0111
740.389.3187
740.474.4410
[email protected] 937.206.9293
[email protected]
614.891.3733
7
13671 Wagram Rd Pickerington OH 43147
in
n
o
i
J
o
J
!
y
a
To d
Become a member of the
Central Ohio Vintage Volkswagen Club
Only $20.00 Annually
Name:
Address:
City:
State:
Zip:
Phone:
Email:
•
•
•
•
•
•
Monthly Gatherings
Shows, Cruise-ins, and Plenty of Fun
Great Friends
Good Food
Share & Educate VW Knoweledge
12 issues of Zundfolge Newsletter
VW’s Owned:
Complete and return to:
Visit covvc.org for more details
$20.00 Annually
Central Ohio Vintage Volkswagen Club
13671 Wagram Rd
Pickerington, OH 43147
Checks Payable to COVVC
Next Meeting: November 12, 2015 7:30PM @ Tommy’s in Dublin