precautions on schematic diagrams

SCHEMATIC DIAGRAMS
CD RECEIVER
KD-R430J
KD-R431EU
KD-R432EN
KD-R434UI
KD-R436U
KD-R437EE
KD-R531E
KD-R431E
KD-R431EY
KD-R432EU
KD-R435U
KD-R436UN
KD-R439UR
KD-R531EN
KD-R531EY
KD-R431EN
KD-R432E
KD-R432EY
KD-R435UN
KD-R436UP
KD-R48EE
KD-R531EU
KD-R54J
(No.MA503<Rev.003>)1/13
■ PRECAUTIONS ON SCHEMATIC DIAGRAMS
z
z
z
Due to the improvement in performance, some part numbers shown in the circuit diagrams
may not agree with those indicated in the Parts List.
The parts numbers, values and rated voltage etc. in the Schematic Diagrams are for
reference only.
Since the circuit diagrams are standard ones, the circuits and circuit constants may be
subject to change for improvement without any notice.
■ PRECAUTIONS ON PARTS LIST
z
z
z
z
z
The parts identified by the
symbol are critical for safety. Whenever replacing these parts, be sure to
use specified ones to secure the safety.
The parts not indicated in this Parts List and those which are filled with lines --- in the Parts No.
columns will not be supplied.
P.W. BOARD Ass'y will not be supplied, but those which are filled with the Parts No. in the Parts No.
columns will be supplied.
When ordering chips, screws etc., place bulk orders (unit of tens) whenever possible to improve
shipping efficiency.
There are cases where the actual implemented parts in the sets and the service parts are different.
When ordering parts, make sure to refer to the Parts List.
■ PRECAUTIONS ON SERVICE
Certain parts of the power circuits and the GNDs differ according to the models. Care must be
taken for the following points as the differences are indicated separately in the LIVE GND ( ) and
the ISOLATED (NEUTRAL) GND ( ).
1.
2.
Do not touch the LIVE GND, or do not touch the LIVE GND and the ISOLATED (NEUTRAL)
GND at the same time. It may cause an electric shock.
Before pulling out the chassis or other parts, make sure to pull out the power cord from the
wall outlet first.
Do not short circuit between the LIVE GND and ISOLATED (NEUTRAL) GND, or never
measure the LIVE GND and ISOLATED (NEUTRAL) GND at the same time using measuring
instruments (oscilloscope, etc.). It may blow fuses or damage other parts.
■ DEVIATION TOLERANCE RANGE DEVIATION TOLERANCE RANGE
F
G
J
K
M
N
R
H
Z
P
+30% +50% +80% +100%
± 1% ± 2% ± 5% ±10% ±20% ±30%
-10% -10% -20% -0%
(No.MA503<Rev.003>)2/13
BLOCK DIAGRAM
CD PLAYER UNIT
SW1, SW2, SW3
DETECT SW
FEED+/LOAD+/-
SDATU
SCLTU
TU.L
TU.R
BTL_DMO, BTL_FMO
BTL_FOO, BTL_TRO
3.3V
FOCUS & TRACKING
COIL
(IC540
VDDM1)
VDD5V
IC532
REG.
1.5V
IC530
IC531
3.3V REG.
1.5V REG.
PON_CD
X701
12MHz
SWITCH UNIT
BACK LIGHT LED
Q632
Q633
D627 to D654, D658, D659
LED
DRIVER
432E series / 437EE / 48EE only
P1
P2
P3
E_MUTE
IC80
IPOD CP
KD-R5x only
LCD
DRIVER
IC701
CPU
AC-GND
BEEP
AMP_STBY
LCDCE
LCDCL
LCDDA
LCDDA
MUTE
D782
IC702 , S701
RESET
except 432E series / 437EE / 48EE
LED
Q881
D891
SW5V, VDD5V,
CD8V, A9V, ILM10V
CTRL1, CTRL2
FAUX-L
FAUX-R
EXT
EACH BLOCK
ACC_OUT
IC901
ACC_IN
MEMORY
ANT OUT
ANTENNA
U type only
REMOCON
10V
J601
CN603
USB
REMOTE
REGULATOR
REMOCON
except EE
AUX
INPUT
SPK
BATTERY
TELMUTE
D+, D-
REMOCON
TEL MUTE
CN901
TELMUTE
KEY1, KEY2
REMOCON
ILL
ILMI
CN601
S601 to S617
KEY MATRIX
KEY0
MEMORY
Q970 , Q971
DIMMER_IN
KEY2
VOL1, VOL2
MUTE CONTROL
BU/SURGE DET
CN701
JS601
ENCODER
BU_DET
VDD3.3V
RESET
Q781 , Q782
VOL1
VOL2
KEY0
KEY1
POWER
AMP.
STBY
AMP_MUTE
531E series
only
FL+/FR+/RL+/RR+/-
IC301
SDKPC
RSTCP
REAR/SUBWOOFER
LINE OUT
(1 pair)
FRONT,
REAR/SUBWOOFER
LINE OUT
(2 pairs)
D781
LCDCE
LCDCL
D627 to D641, D646 to D654
D656 to D659
IC681
FLOUT
FROUT
MUTE
SDACP
REAR
AUX IN
except 531E
series
E.VOLUME
D780
COM1 to 4
IC661
D655
LINE MUTE
OFFSET
FAUX-L, FAUX-R
X702
32.768kHz
S1 to 50
LCD DISPLAY
Q780 , Q321 , Q341
RLOUT, RROUT
IC161
DC_ERR
DI1
RAUX-L
RAUX-R
CD.L
CD.R
VDD5V
J321
TRK+/FOCUS+/-
1.5V
J120
IC771
EPROM
FWD, REV, DRVMUTE
IC501
BTL DRIVER
J1
ANT
IC1
FM/AM TUNER
PSW, SW1, SW2, SW3
VF1, VF2, VT1, VT2
MD, LD, Vc (VREF)
CN102
PICK UP
REST (PSW)
CN502
CD PICK UP
CN101
LOAD MOTOR
SP+/FEED+/LOAD+/FOCUS+/TRK+/-
CMDREQ, CMDSO, CMDSI
CMDBUCK, CMDCCE
CDRESET, SRAMSTB, CDMUTE
BSIF_REQ, GATE
LRCK, BCK, DATA
X540
16.934MHz
RF AMP
X1
4MHz
CD.L, CD.R
CD LPF
IC540
Q540
CD_MD, LD
VREF
FEED MOTOR
IC580
CD.L, CD.R
VF1, VF2
VT1, VT2
SP+/-
SPINDLE MOTOR
SW1
REST SW
ELECTRIC UNIT
SW1
SW2
SW3
AUX-L, AUX-R
USB5V
OE REMOTE
431E series, 432E series,
531E series only
USBPON, FREQ_SEL
IC981
VDD3.3V
MEMORY
DC-DC USB5V
USB5V
D+, D-
SW3.3V
Q951 , Q952
SW3.3 CCT
IC931
3.3V REG.
VDD5V
SW5V
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)3/13
ELECTRIC UNIT-1
R335
J321
R323,R333
* REMARK
MODELS
3 pairs
KD-A535J
QNN0866-001
NIL
NIL
2 pairs
KD-R530J,KD-R536U SERIES,KD-R54J
KD-R537EE,KD-R538J,KD-R531E SERIES
QNN0868-001
NIL
0
1 pair
KD-R430J,KD-R436U SERIES,KD-R435U SERIES
KD-R434UI,KD-R431E SERIES
KD-R432E SERIES,KD-R437EE
QNN0874-001
0
0
SUB-R
FRONT-R
REAR-R
J321
SUB-L
*
REAR-L
FRONT, REAR / SUB-WOOFER
LINE OUT
(2 pairs)
531E series/54J only
FRONT-L
REAR / SUB-WOOFER LINE OUT
(1 pair)
except 531E series
KD-R48EE
NO LINEOUT
MAIN PWB: GEB10316A
180
R257
0V
FOR 3 PAIRS L/O ONLY
0.6V
0V
IMX9-W
Q251
0V
0.6V
10/50
C320
0V
10/50
C330
0
* R335
47k
4.7k
R251
4.7k
R252
D321
BAW56-TP-X
10/50
-
22k
C252
0
R324
10/50
0
47k
LTA024EUB-X
C251
0
R323
R334
D251
BAW56-TP-X
0
R333
FOR 1 AND 2 PAIRS
L/O USE ONLY
-
LTC024EUB-X
22k
22k
0.1
NIL
22K
BU_DET
RL+
R302
CDRESET
47k
STAGE SETTING
KD-R531E
1.03V
KD-R537EE
SERIES
STAGE 1
STAGE 2
R764
33K
R766
15K
R765
22K
R767
27K
1.02V
1.77V
27K
22K
15K
33K
1.46V
2.27V
8.2K
0.57V
KD-R530J
22K
27K
15K
33K
1.8V
2.26V
39K
0.55V
8.2K
33K
1.03V
15K
KD-R536U
SERIES
39K
0.57V
8.2K
15K
33K
47K
27K
22K
0V
1.49V
47K
33K
15K
NIL
15K
15K
33K
2.25V
33K
15K
33K
2.25V
2.26V
RST
22K
22K
27K
RST
3.3V
Q780
LTA024EUB-X
!
C901
2700/16
R788
R941
(1/8W)
4.7k
D942
MBRX130-TP-X
C942
C941
0.1
EXT
ANT OUT
D901
D780
BAW56-TP-X
-
3.3V
4.9V
4.9V
14.3V
SW5V
ACC IN
4.9V
VDD5V
GND
ACCOUT
CTRL1
OUTFL+
MUTE
OUTFLGND
OFFSET
*POWER CORD ASS'Y
18
!
ILL
MEMORY
OE REMOTE
REAR RIGHT(-)
REAR LEFT(-)
REAR LEFT(+)
FRONT LEFT(-)
FRONT LEFT(+)
GND
R882
4.7k
0V
C881
22/16
0V
R883
OPEN
17
14
TEL MUTE
16
13
15
12
11
REAR RIGHT(+)
10
9
8
7
1
C851
27k
*
3.3V
R881
R891
TEL MUTE
R893
12k
0.1
C891
R892
68k
0
CN901
QNZ0607-001
BACKUP
RL-
RR-
RR+
FL+
RL+
FR+
R902
D851
MBRX130-TP-X
D852
MBRX130-TP-X
*
R851
4.7k
(1/8W)
ACC IN
10k
(1/4W)
R901
C910
C911
C902
0.47
R906
5.6K
(1/10W)
10/25
10
C908
C909
FOR U VERSION ONLY
330/6.3
C907
3.9K
(1/4W)
0V
VCC
330/6.3
D902
MBRX130-TP-X
100/16
C906
47/16
C904
C913
0.1
C905
4.7k
47/16
C903
VCC3/4
4
A2
3
VDD
0V
D971
0V RKZ6.8B2KG-X
47k
R972
10k
2.9V
R974
0V
Q971
LSCR523UB-X
R970
47k
0.6V
BU DET
C985
R983
BD9673EFJ-X
10
IC981
Q970
LSCR523UB-X
5
1.6V
4.7u
6
3.2V
SYNC
L982
EN
FB
R971
10k
0V
D970
RKZ6.8B2KG-X
R976
68k
(1/10W)
R975
47k
(1/10W)
10
3
VC
20k
SURGE DET
POWER CORD
MODELS
QAM1326-001
KD-R430J,KD-R438J,KD-R530J,KD-R54J
QAM1328-001
KD-R435/6U SERIES,KD-R434UI
QAM1329-001
KD-A535J,KD-R538J
QAM1330-001
KD-R536U SERIES
QAM1344-001
KD-R48EE,KD-R437EE,KD-R537EE
QAM1345-001
KD-R431/2E SERIES,KD-R531E SERIES
C989
7
9.8V
4
14.2V
8
2
BST
R965
1
VCC
GND
C986
C983
6800p
27K
R982
110K
R986
DB22306-X
D981
10
LX
4.7k
270
C987
GND
SCL
WPIN
1.0V
91K
C981
R962
R981
R984
0.1
0V
SDA
3.3V
OUTRL-
R973
BUDET
0.1
C990
5.1V
EPROM
0V
GND
14.3V
10k
1K
R951
C954
ILMI
R894
C984
47k
L981
22u
3.3V
OUTRL+
SPK BATTERY
R718
3.3V
AC-GND
*
ANT
R773
10
VDD
R908
R904
0.1
0.1
4
3
C912
1
2
0.1
C933
4.9V
DIMMER_IN
4.7k
INRL
REMOTE
BU_DET
3.3V
INFL
* R777
0.01
C932
330/6.3
0V
C735
0.01
3
4.4V
CTRL2
3.3V
AUDIO OUT
VDD5V
D891
MC2836-X
C704
100/16
OFFSET2
PRE-GND
REMO
C736
LTC014EUB-X
Q881
3.3V
INFR
FOR U VERSION ONLY
330
Q952
INRR
C314
1
MBRX130-TP-X
47k
R743
7
3.3V
4
D781
BAW56-TP-X
3.3V
0V
AUDIO F
8.6V
14.3V
(3.3V) 1.6V
CD OUT
1.2V
ILM F
0V
10 11 12 13 14 15
11.5V
9
( )
C915
LTC044EUB-X
0V
POWER IC MUTE
2SA812A/5-6/-X
NC
NC
NC
NC
IC702
8
(7.9V)
SW3 (LOAD END)
PON_CD
CD_MUTE
SRAMSTB
CMD_CCE
CD_RST
NC
NC
R745
100
-
R784
4
3
2
1
5
6
7
3.3V
(3.3V)
(3.3V)
0V
(3.3V)
(3.3V)
(3.3V)
(3.3V)
CMD_SI
CMD_SO
NC
ACC DET(PS1)
7
TM
3.3V
3.3V
DATA
6
10k
10k
R739
100
100
R715
BCK
5
0V
47k
TELMUTE
C714
0.1
4.7k
R771
0
R708
R713
LRCK
4
D941
2.6V R952
0V
3.3V
330
(1/8W)
47k
47k
R726
R723
SW3
PON_CD
SRAMSTB
CDMUTE
CDRESET
CMDCCE
CMDSI
CMDSO
CMDBUCK
(3.3V)
CMD_BUCK
REG1-3
3.3V
DATA
LRCK
REG2-2
BCK
(3.3V)
(3.3V)
(0V)
4.7k
L703
Q951
R742
0V
R781
RIPPLE
L901
10K
47k
R727
10K
0.1
C713
SWDIO
BU_DET
0V
0V
3.3V
DVSS
DVCC3
SWDIO
BU_DET(PS2)
SWCLK
FWD
REMO
REC2-1
3.3V
3.3V
ILM OUT
47k
R736
SWCLK
0V
3.3V
(0V)
REV
4.7k
R774
R770
3.3V
SW3.3V
0V
0V
A1
A0
0V
DC-DC USB5V
C723
0.047
1
2
IC771
BR24T02FJ-W-X
RESET
KD-R54J
27K
3
1.2V
47k
R735
FWD
REV
(0V)
GATE
CMD_REQ
DRVMUTE
LCD_CL
NC
VDD
3.3V
C931
3.3V 0.1
22
47k
(0V)
(3.3V)
(0V)
3.3V
0V
1.6V
100
R702 2.2K
0V
LCDCL
LCDDA
RXM
0.1
0V
1.01V
2
R987
47k
3.3k
3.3k
R728
R753
R731
GATE
CMDREQ
SDATUVR
DRVMUTE
8
NIL
KD-A535J
0V
GND
KD-R430J
KD-R538J
47K
2.24V
NIL
VDD3.3V
47k
SN
47k
GND
1.46V
VOUT
0
C315
39K
VIN
GND
XC6213B332NG-X
C703
0.01
R744
3.3V
24k
NC
22K
DIMMER_IN
3.3V
R746
XC6120N282NG-X
27K
AMP_STBY
3.3V
ACCDET
C706
1.46V
C731
0.1
47k
USBPON
0.0V
15K
HC1-2
47k
LV5680P
1
R907
4.6V
CTRL
0V
1.1V
0.0V
33K
(3.3V)
4.6V
0V
R747
47k
22K
REG1-1 31
S701
QSW0648-001Z
27K
KD-R438J
IC901
IC931
L703:NQR0154-006X
R730
1.01V
KD-R435U SERIES
KD-R436U SERIES
KD-R434UI
LCDCE
BEEP
DC_ERR
TXM
KD-R48EE
100
3.3V
R534
FREQ_SEL
* R785
1.02V
R706 910
*
R725
47k
15K
LCD_DA
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
RESET
33K
R767
RSTCP
9
47K
15K
R765
3.3V
8
0.1
33K
R766
3.3V
7
0.1
R764
CP RESET
6
R720
STAGE 2
SCLTUVR
BSIF_REQ
(0V)
SDA CP
5
C717
KD-R437EE
SERIES
STAGE 1
BSIF-REQ
4
C715
KD-R431/2E
R754
R749
R750
SDACP
3.3V
SCL CP
3
R758
100k
D120,D121,D130,D131:RKZ6.2B2KG-X
STAGE SETTING
* R751
3.3k
TP9
3.3k
TP10
TP8
R752
TRCLK
TRDA1
2
* R766
R132
470
3.3V
3.3V
3.3V
3.3V
NC
USB_PON
1
R703
100 KEY0
REG1-2
3.3V
LCD_CE
47K
4.7k
R724
4.7k
DC OFFSET DET 33
(FOR st ONLY)
NC 32
FREQ_SEL
* R764
RAUX-L
KEY0
99 KEY1
0V
* R767
0.1
D131
D130
4.7k
98 KEY2
C132
D121
4.7k
* R765
1
C131
1
NQR0007-002X
D120
RAUX-G
4.7k
R762
TEST1 34
3.3V
C130
R131
R130
L
RAUX-R
C122
R768
R763
2.6V
DVCC3 35
97 STAGE 1
R772 4.7k
R122
47K
R121
C120
R120
C121
1
3.3V
R732
96 STAGE 2
R712 100
KEY1
*
SN 37
DVSS 36
NC
KEY2
NO USE 38
95 TEL MUTE
BEEP
100/10
C963
C707
*
4.7k
93 ENC2
94 AVCC3
1.48V
R733
NQR0007-002X
0V
NC 40
PNO_FL 39
MODE
10k
DIMMER 41
IC701
JCV8019
!
92 RGB_CLK
0V
R760
TELMUTE
91 NO USE
R701
VOL2
*
/RESET
0.1
910
VREFH
100k
* R737
AMP STBY 42
AVSS
R757
C716
RGBCLK
0V
47k
0V
R759
KEY1
KEY1 20
REGVCC3
90 NO USE
*
3.3V
KEY0
KEY0 19
NC 43
CPU
89 /NMI
3.3V
10
10
C720
C722
C726
0.01
USB5V 17
HC1_2 44
88 D-
ENC1
D-
D- 16
87 D+
MUTE
2
0V
AMP_MUTE
0V
1
27
PSW
3.3V
5
R790
NC 45
2.5V
6
D-
86 DVSS
DC OFFSET DET
D+
D+ 15
MODE0 MODE1
* R82
7.2V
OUTRR+
QQR1884-001
3.3V
NC
L701
4.7u
8
15k
RCA MUTE 46
SW1
SDATUVR
0V
AMP MUTE 47
85 DVCC3
3.3V
270
27
SW1 49
PSW(RST SW) 48
84 X2
3.3V
USBGND 14
nRST
!
R909
27k
50
SW2
R778
R789
C732
NQR0007-002X
SDA
1.5M
3.3V
270
D+
83 CVSS
DVSS
R776
LCDDA
LCDDA 13
15k
82 X1
FREQ_SEL
R775
LCDCE
LCDCE 12
R
TRDA0
47k
0V
LCDCL
G
SCL
C914
3300P
SCLTUVR
3.3V
VOL2
VOL2 10
LCDCL 11
J120
QNS0307-001
3.3V
ILL11.5V
R779
0V
1.5V
820
0V
R721
1M
R782
* R738
15p
SW2 (EJECT END)
REMOCON
0.1
81 CVCC3
0V
C705
1.5V
SDA TU EVOL EEPROM
C725
VOL1
REAR AUX IN
3.3V
SDACP
REGULATOR
3.3V
FL-
3.3V
R780
REMOTE OUT
VCC
3.6V
GND
( )
18p
RGBCLK
XT1
XT2
X701
QAX0966-001Z
SCL TU EVOL EEPROM
C724
REMOCON
USB5V 18
TP6
USBPON
0.47
1V
1.6V
L702
4.7u
C718
3.3V
10K
47K
10K
X702
QAX0401-001
0V
( )
9
SCKCP
VSS
7.2V
0V
NOT USED FOR KD-R48EE
( )
7
8
0V
10k
( )
To SWITCH UNIT
CN601
6
VOL1
0.047
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
C702
R786
Q781
LTC024EUB-X
* C80
D782
RKS801KF-X
IC80
RSTCP
10p
C701
10p
0.1
BAW56-TP-X
*
MFI341S2313-X
FAUX-R
1
3.3V
11.5V
RGBCL
C111
KEY2
C708
10k
0V
D783
IPOD CP CIRCUIT
0V
0.01
5
REMOCON
0.1
R761
KEY2
C712
R740
R741
VOL1
3
4
FAUX-G
1
10
USB5V
2
C102
C733
C734
470
AUX-R
AUX-G
D-GND
0
R112
C112
1
0.1
AUX-L
47K
R110
CN701
R111
C110
0
D111
R101
C100
R102
D110
FAUX-L
1
SCKCP
C101
0
QGZ1102J1-20
( )
D101
R100
C737
0.01
3.3V
D100,D101,D110,D111:RKZ6.2B2KG-X
D100
3.3V
R722
C730
0.01
HC1-2
TRDA2
C728
0.01
* C721
0.01
SW2
TRDA3
SW1
PSW
C729
10
SW3
)
C727
27P
CD8V
(
DRVMUTE
TP7
REV
0.022
( )
100K
Q782
LTA024EUB-X
3.3V
14.4V
R303
R783
FWD
0V
7.2V
FL+
R304
LINE MUTE
CD8V
7.2V
C311
SRAMSTB
DETAIL DEBUGGING
USE ONLY
(1/8W)
7.0V
RL-
1
CMDCCE
BTLGND
1 10/16
NCB21AK-105X-A
* R310
CMDBUCK
CDMUTE
7.0V
OUTRR-
F901
FUSE 10A
QMFZ064-100-J1
RESET
A9V
QERF1CM-106Z-E
C313
C310
1
7.0V
2
0V
3
7.1V
4
N
0.47
7.1V
22/16V
5
0.47
7.1V
6
C303
C309
VCC1/2
7
C307
7.2V
OUTFR+
8
0.47
QEKJ1CM-226Z-S
STBY
9
RR+
OUTFR-
25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10
N
0V
GND
1N5401-BPC04
750
7.2V
TAB
D704
10
14.4V
0.022
FL-
R310
* R367
RR-
FR-
360K
0.47
6
4.7K
7.2V
C312
C304
0.47
* R363
FR+
5
R701
C308
* R368
RLOUT
N
0.47
4
6.8K
C302
3
NIL
N
C306
3.3V
ANTENNA
5.1K
0.47
0.47
* R364
FLOUT
0V
7.1V
FRONT RIGHT(-)
C160
10/16
QEKJ1CM-106Z-S
* R361
* R365
USED
0 ohm
R365~R368
FROUT
0V
FR-
C301
C305
* R366
NIL
NIL
R361~R364
* R362
TB2931HQ
0
REMOTE/P-con
* L161
R169
RROUT
TDA7720-X
USED
R168
3.3V
0
U VERSIONS
TDA7718B-X
R150,R152
R151,
* R152
!
RAUX-R
RAUX-G
RAUX-L
FAUX-R
FAUX-G
!
FAUX-L
0
R151
E-VOL IC
IC161
* C166
3.3V
3.3V
3.3V
3.3V
3.3V
3.3V
QTE1V67-475Z
4.7/35
C174
R150
0
J/E/EE VERSIONS
R306
FRONT RIGHT(+)
3.3V
4.7/35
C162
!
MODELS
IC301
!
POWER AMP.
R307
C301-C304:QTE1C66-474Z
C305-C308:NCB21CK-474X-A
BEEP
CMDSO
CMDSI
22k
0.01
LRCK
To ELECTRIC UNIT-2
R253
LTC014EUB-X
10k
QEZ0937-278
NIL
1
4.7k
R358
0V
Q321
IMX9-W
0V
0V
0.6V
0V
0.6V
R357
4.7k
FOR 2 AND 3 PAIRS L/O ONLY
4.7k
0V
Q341
IMX9-W
C721
180
R258
180
R342
180
180
R352
0V
0V
R347
4.7k
-
100 ohm
NQL553J-27NJ
NIL
0 ohm
NIL
2
0.047
NIL
R160
R751
3
10k
LTC044EUB-X
MFI341S213-X
NIL
C166
COMPONENTS IN ( ) INDICATE NOT USE.
2
3.3V
2p
FRONT AUX
QTE1V67-475Z
CD.R
20
CD.L
BCK
C794
NIL
6
330
R5XX SERIES
NIL
5
ACC
CREF
3.3V
R794
GATE
C173
1
RKZ6.2B2KG-X
CD
TU.R
1K
D704
C80
4
OFFSET
QD2R_DSEL
3.3V
NIL
R777
DATA
TU.L
NIL
BSIF_REQ
C161
1
47K
!
22K
10k
27K
R161
R785
DC_ERR
0 ohm
C177
1
C738
0.01
CMDREQ
TUNER
KD-R437EE
KD-R48EE
KD-R537EE
2.2K
R4XX SERIES
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
OFFSET2
QD2G_QP2R
14
2.2K
Ipod
IC80
( )CD MODE.
UNLESS OTHERWISE SPECIFIED.
3.
AMP_STBY
QD2G
13
R738
1
AM MODE.
ALL RESISTORS ARE 1/16W 5% METAL GLAZE RESISTOR.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTANCE VALUES ARE IN OHM.
AMP_MUTE
QD2L
12
MAINGND
2
22k
MUTE
QD1R
11
0V
3
22k
E_MUTE
QD1G
10
REMOTE
1
6
2.
R255
---FM MODE.
RROUT
QD1L
9
VDD5V
2
5
RLOUT
SE3R
8
KD-R430J/R438J
KD-R435/6U SERIES
KD-R434UI
KD-R530J/R54J
3
4
100p
R256
R254
330
RR/SUBR
SE3L
7
KD-R431/2E SERIES
KD-A535J/R538J
KD-R536U
KD-R531E SERIES
6
100p
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
CONDITION
R330
330
RL/SUBL
SE2R
6
OE &
180
0V
SE2L
5
PON_CD
5
D341
BAW56-TP-X
GND
SE1R
4
910
NIL
3.3V
SE1L
3
R737
0.06V
4
C253
REAR AUX
2
47K
10/50
10/50
15
SWR
0V
4V
16
SWL
4V
17
1
R759
C340
C350
RR/SUBR
RL/SUBL
FROUT
RROUT
18
OUTRF
4V
19
OUTLR
4V
20
OUTRR
OUTLF
4V
WINTC
4V
21
MUTE
4V
22
A9V
S.GND
0 ohm
22k
C319
C318
C317
1
RLOUT
1
C316
1
C171
FLOUT
C170
C168
0.1
E_MUTE
C169
2.2k
3.3V
8.2V
3.3V
3.3V
3.3V
23
CD.L
CD.R
22k
C254
R320
330
R167
R163
QEKJ1CM-107Z-S
C172
100/16
100
R162
0
OTHER MODELS
24
VDD
RGB
25
SCL
NIL
NIL
26
SDA
NIL
27
DC_ERR
10P
28
* IC161
NQL103J-10NX
R9
* R169
0
0.22
L10
KD-R537EE/
KD-R530J
KD-R536U SERIES
KD-A535J/
KD-R438J
KD-R538J
* R168
OTHER VERSION
C28
3.3V
4.7u
L7
TU.R
J VERSION
22k
L161
TU.L
100p
R341
R82
27P
L4
QQR1872-001
TUNER
R165
0
4MHz
X1
QAX0952-001Z
C14
C23
OFFSET
XTAL
0.1
C7
E.VOLUME
12p
C20
0.22
1
0.1
C15
4
C5
15p
C13
6
L3
5V
0.4V
8.5V
4.2V
3.1V
3
100
SCL
DGND
TEST
16
6.2V
RSSI
15
6.2V
MPXOUT
14
7
SDATUVR
SDA
MPXIN
13
2
SCLTUVR
VREF
AMIFAGC2
12
3.2V
AGND
11
3.5V
ROUT
10
2.0V
LOUT
9
0V
AMRFAGC
8
3.8V
VCC
7
3.8V
GNDRF
6
1.8V
FMRFIN1
5
0V
FMRFIN2
4
0V
AMRFDEC
3
3.1V
AMRFIN
!
2
1
R340
330
0V
3.3V
17
1
8
0.6V
0.1
18
VREG
3.3V
3.9V
19
100p
R321
22k
220
WIN_IN
IC1
TEF6614TV1S4-X
20
C341
R351
L11
NQR0251-002X
21
1000P
0.27u
C21
C24
100/16
(1/10W)
R8 22
22
VCC
7.1V
8.5V
C19
0V
23
VCO
5.6V
24
GNDRF
4.5V
PLLREF
25
PLL1
PLL2
C22
1
0.1
C18
0.01
C17 0.1
3.5V
4.7k
C16
0.01
1.5V
2.2V
R4
C11
0.01
C12
0.01
0V
1.5V
C10
1
AMSELIN1
0V
AMSELIN2
3.0V
L6
560u
AMIFAGC1
1.4V
6.8V
AMSELOUT1
8.5V
6.8V
L5
560u
C6
AMSELOUT2
8.5V
0.47u
L9
C3
C27
2p
6P
680k
680k
R2
R1
C29
0.47u
26
0V
R9
D1
C28
*
0V
1.8u
L1
4.7u
NAF0029-001X
L2
7p
27
2.9V
L8
C2
28
C4
C1
1000P
29
R7
C321
0
L12
NQR0251-002X
220
*
L10
R3
R10
C26
470p
30
SCL
C8
0.1
R6
100p
R331
R350
330
0
0.01
R372
SDA
*
*
31
R332
R373
C368
32
C351
100p
FM/AM
TUNER
R349
TOMIC
C331
* R160
J1
QNB0358-001
*
NOTES
LINE OUT
R322
ANT
!
Parts are safety assurance parts.
When replacing those parts make
sure to use the specified one.
1.81V
1.83V
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)4/13
ELECTRIC UNIT-2
MAIN PWB: GEB10316A
R504
R507
TRK+
56K
FOCUS+
BTL_FOO
R505
R511
100K
13K
FOCUS-
CD LPF
BTL_TRO
270k
TRK-
R596
BTL_FMO
C585
R506
R517
47k
R581
33k
C504
C582
10k
R599
47K
47k
C586
4.7/25
QERF1EM-475Z-E
10k
10k
R584
R583
C590
47/6.3
QEKJ0JM-476Z-S
CMDREQ
R594
DATA
10
10k
10k
R589
R590
GATE
R592
R579
MAINGND
20k
BCK
LRCK
CMDSO
CMDSI
C592
R587
A9V
VDD5V
C591
47/6.3
QEKJ0JM-476Z-S
220K
C595
68p
CD.L
PON_CD
BSIF_REQ
8
8.5V
4.2V
7
4.2V
6
S.GND
0.1
VCC
C588
+
4.2V
R510
C507
DSPR
OPEN
CMDBUCK
To ELECTRIC UNIT-1
CMDCCE
10k
CDRESET
SRAMSTB
CDMUTE
68p
BTLGND
CD8V
0
R518
0.1
* C501
C514
100/10
4.2V
4.2V
4.2V
0v
GND
IC580
NJM4565E-X
REG0
VREF
EN1
EN2
REG5
5V
4.4V
47K
0.1
R514
110K
R501
+
C587
C513
0.1/50
CD.R
1
R588
C583
33K
0.22
2
-
5
3.3V
VCC
NC
7V
NC
NC
0V
0V
1.4V
REV
0V
FWD
0V
VG
CP
12.5V
IC501
LV8281VR
C503
OPEN
R519
C506
3.5V
C505
0.047
!
TSDO
FB
GND
NC
SWREG
VIN4
VCONT
NC
VIN3
VIN2
VIN1
NC
VM2
CPC
NC
VM1
PGND2
PGND1
7V
0V
9.7V
NC
NC
NC
0V
VO1+
LO-
0V
3.6V
VO1LO+
C508
OPEN
3.6V
VO2-
VO2+
VO3+
3.6V
VO4-
10 11 12 13 14 15 16 17 18 19 20 21 22
VO4+
9
VO3-
8
4
3.6V
7
3
3.6V
6
2
3
-
5
1
C509
OPEN
20k
4
44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23
C510
OPEN
R593
C594
68p
R582
0.1
R597
47k
47k
7V
1.6V
0V
1.6V
0V
1.6V
1.6V
1.6V
7V
0V
0V
0V
0V
C512
470P
R516
R598
220k
3.6V
C511
470p
3.6V
3.6V
3.6V
3.6V
VREF
C593
DSPL
TSDO
68p
QERF1EM-475Z-E
4.7/25
C584
BTL_DMO
30K
FWD
R595
REV
DRVMUTE
SW3
D502
SW1
SW2
GS1J-LTP-X
CN502
0
PON_CD
CMDSI
CMDSO
CMDCCE
CDRESET
SRAMSTB
VREF
C571
47p
C566
0.1
10K
4
0
R530
0.1
3
1
C531
C530
1
4
3
1
1.5V
0.1
XC6213B152NG-X
C533
DATA
VOUT
C532
100
1
R562
2
L563
4.6V
VIN
GND
0V
D1.5V
100
BCK
0V
IC532
0V
1.4V
R558
1M
C564
0.1
0V
R557
2
1.5V
470
3
3.3V
1
0.1
R556
0
0V
4.6V
VIN
GND
VOUT
C565
XC6213B152NG-X
X540
QAX0929-001Z
16.9344MHz
1.5V
CTRL
0V
1.5V
0.1
4.6V
4
CMDREQ
3
BSIF_REQ
100
0.1
GATE
100
R559
C535
100
R560
0V
C534
R561
0V
1
0V
1.7V
L561
3.3V
NQR0154-006X
3.3V
1.7V
C562
10
C561
10
L562
NQR0154-006X
0V
CDMoN3
R555
L531
4.7
R554
NQR0154-006X
4.7
40
Pio13/CDMoN1
Pio14/CDMoN2
39
38
LRCK
0V
0V
2
VDD3 61
R566
R565
3.3V
0V
BUS1 63
BUS0 62
R567
3.3V
2.5V
BUS2 64
Pio12/CDMoN0/FGiN
37
0V
0V
Pio10
Pio11
36
35
0V
Pio9
34
0V
Pio8
DMo
VDD1-3
32
31
33
0V
0V
1.5V
FMo
FMoS
30
29
1.6V
0
100
R563
FOK
IPT
47K
CDMUTE
0.033
NQR0154-006X
R564
R553
0.068
C557
NQR0154-006X
3.3V
L565
L564
C559
0.1
680P
C556
* R512
330P
C555
BTL_FOO
C554
BTL_DMO
TE
4700p
DVSS3R
NQR0154-006X
3.3V
/DET
C552
0.033
C553
VSS-3
CD_MD
Ro
0V
CTRL
2
10K
100
100
100
R568
R569
R570
0V
BUS3 65
BUCK 66
R571
3.3V
/CCE 67
0V
2.5V
3.3V
0V
MS 68
/RST 69
TEST 70
1.6V
VSS-1 72
VDD-1 71
0V
0V
1.5V
PDo 75
VDDM1 74
/SRAMSTB 73
100
C567
10K
1
0.1
0.1
R572
100K
C569
C568
0.1
C570
330K
R573
LDo
1.6V
4.7K
D540
1.6V
MDi
RKS801KF-X
R550
1.6V
DVDD3R
FE
LASER DIODE CIRCUIT
LPFN 77
Lo
DVDD3L
AVSS3
TRo
2.2V
TNi
VRo
Foo
1K
DVSS3L
28
R549
0V
TPi
21
1.9V
2.2M
XVSS3
27
Q540
R545
FPi1
26
0V
Xi
0V
1.6V
Xo
1.6V
1.9V
XVDD3
FPi2
1.9V
VT1
VDD1-2
FNi1
0
1.9V
VSS-2
FNi2
0
VT2
RVSS3
FSMoNiT
0.1
10
100K
1.8V
C551
C550
R548
R546
R547
4.7
1.9V
IC540
JCV8022
* R513
1.9V
VF2
RFo
* R508
0V
Pio2
Pio1
Pio0
0.1
1.3V
!
BTL_FMO
0.1
C549
RF
AGCi
BTL_TRO
1.6V
Pio3
RFEQo
DCoFC
3.3V
DSPL
RFRPI
1.6V
1.6V
2SA2188/F/-X
2.4V
60
5
1.6V
VF1
3.0V
41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59
1.6V
3.3V
0V
DSPR
3
4
0.1
C547
0.015
6
C545
RFI
7
SLCO
8
1.6V
1
68p
Pio4
3300p
9
C548
Pio5
C544
VREF
C546
Pio6
20 19 18 17 16 15 14 13 12 11 10
AFR
VCOI
RVDD3
AVDD3
C543
1.6V
TEi
3.3V
0.01
25
0.1
VOUT
IC531
Pio7
24
C542
1.3V
220
1.6V
2200p
VIN
GND
XC6213B332NG-X
1
0.1
C541
4.6V
CTRL
0V
2
R540
C540
TMAX 76
FOCUS+
3.3V
26
VCoF 80
FOCUS+
IC530
3.3V
FOCUS-
0
24
* R509
TRK+
FOCUS- 25
TRKTRK+
0.1
22
TRK- 23
0.9V
GND
CMDBUCK
DRVMUTE
R503
FWD R502
LOAD-
LOAD+
FEED-
20
LD 21
C572
GND
FEED+
C558
18
FEED- 19
C573
FEED+
SP-
15K
SPINDLE- 17
VREF
SP+
0.015
16
HC1-2
LOADLOAD+
1.6V
SPINDLE+
0.1
1.6V
LOAD+ 15
C516
1.6V
14
R574
12
PVREF 79
LOAD-
3.3k
CD_MD
RFZi
GND
HC1_2 13
R575
VT1
VREF
1500p
22
To CD PLAYER UNIT
CN101
C575
1.4V
MD 11
10K
LPFo 78
10
PSW
C576
0.01
VREF
VT2
10K
R577
RFRP
8
VT1 9
C574
PSW
SW1
23
VT2 7
R576
1.9V
6
SP+
VF2
VF2 5
SW1
SP-
SW2
4
FEED+
SW2
FEED-
SW3
2
D3.3V 3
HC1-2
REV
VF1
VF1 1
SW3
0
PSW
QGF1040F1-26
!
Parts are safety assurance parts.
When replacing those parts make
sure to use the specified one.
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)5/13
SW PWB:GEB10318A
COM1
S50
COM2
COM3
S49
COM4
S48
S47
S46
S45
S44
S43
S42
S41
S40
SWITCH UNIT
LCD DISPLAY
40 41 42 43 44 45 46 47 48 49 50 51 52 53 54
TAG
HD
MENU
ST
LOUD
HOLD
TEXT
AF TP
NOT FOR EE VERSION
REMOCON
IC681
OUT
3.3V
GND
OV
AUX-IN
KSM-2003TN5B
VDD
3
3.3V
2
C682
R672
R671
C672
0.0047
C671
0.0047
1
0.1
J601
QNS0299-001
P
R681
330
(1/8W)
L670
RKZ3.3B2KG-X
NQR0007-002X
D681
L673
NQR0007-002X
L674
NQR0007-002X
1
DI1
2
3
4
5
6
7
8
9
1
2
AUX-G
3
DGND
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39
(1/8W)
QLD0695-001
ENCODER
CN601
QGZ1102K2-20X
AUX-L
AUX-R
4
KEY2
R676
C665
5
11.5V
1.5
REMOCON
1
R675
NC
C601
C602
11
S39
S38
S37
S36
S35
S34
S33
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
S9
S8
S7
S6
S5
S4
S1
LCDCE
S3
VOL2
10
LCDCL
S2
1
2
B
4
VOL1
5
SW
9
VOL2
A
3
COM
12
LCDDA
D+
RKZ5.1B2KG-X
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
RKZ5.1B2KG-X
D662
D664
RKZ5.1B2KG-X
D663
S34
S35
S36
S37
S38
S39
S40
S41
S33
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
S42
S44
S45
S46
S47
S48
S43
2.4V
2.4V
2.4V
2.4V
2.4V
2.4V
LIGHTING DISPLAY
2.4V
S49
S50
COM4
COM3
JS601
QSW1231-002
COM2
COM1
USBGND
SELECT
17
USB5V
18
19
KEY1
20
R677
D652
2.4V
* D647
BRIGHT
2.4V
2.4V
0.01
*
0V
0V
2.4V
LCDCL
R666
100
2.4V
LCDDA
R667 100
2.4V
S617
6
S616
5
S615
4
S614
3
S613
2
60
21
61
20
62
19
63
18
64
17
S31
2.4V
S30
2.4V
S29
2.4V
S28
2.4V
S27
2.4V
S26
2.4V
S25
2.4V
S24
2.4V
S23
2.4V
S22
2.4V
S21
4
2.4V
S20
3
2.4V
S19
2
2.4V
S18
2.4V
S17
R691
10K
C692
USB
C691
LF691
CN603
10
QNZ1076-001
NQR0682-001X
R678
0
C680
C679
27p
1
VCC
DD+
GND
5
6
7
8
9
10 11 12 13 14 15 16
D692
D691
4
RKZ5.1B2KG-X
3
2.4V
R650
2
S16
1k
2.4V
Q631
22
S15
KEY2
59
2.4V
820
23
S14
820
24
2.4V
1.2k
58
1
LSCR523UB-X
R651
0V
25
IC661
PT16580-LQ
57
2.4V
1.8k
*
P3
56
S13
2.7k
Q632
2SC6046-X
*
26
S12
R612
P2
27
55
2.4V
R613
5.1V
28
54
S11
R614
P1
LCD DRIVER
53
2.4V
27p
2.7k
R615
1.7V
R665 100
Q633
*
R616
3.2V
LCDCE
29
S32
R652
0.78V
EQ
1K
1K
C662
C661
R648
1K
1.5K
R621
(1/8W)
R620
R623
(1/8W)
(1/8W)
R622
*
(1/8W)
R646
R647
(1/8W)
*
(1/8W)
R645
(1/8W)
*
(1/8W)
R644
R643
(1/8W)
*
(1/8W)
R642
(1/8W)
R641
R640
*
(1/8W)
(1/8W)
R639
R638
*
(1/8W)
(1/8W)
(1/8W)
*
R657
R656
R655
(1/8W)
*
(1/8W)
R654
R637
(1/8W)
*
(1/8W)
R635
R636
(1/8W)
*
(1/8W)
R634
R633
(1/8W)
*
(1/8W)
R632
(1/8W)
(1/8W)
*
R631
R630
R629
(1/8W)
R628
(1/8W)
R626
R627
(1/8W)
(1/8W)
R625
(1/8W)
R624
*
VDD1
VDD2
R663
30
52
2.4V
MENU
*
5.1V
31
51
2.4V
S606
*
R662
VDD
32
50
2.4V
S607
*
620
* D654
6
RKZ5.1B2KG-X
* D651
5
620
R649
* D649
2
(1/8W)
* D645
VOL
D660
* D643
VOL
(1/8W)
* D659
VOL
49
S10
S608
*
(1/8W)
KEY1
820
BACK
* D657
VOL
2.4V
S9
BRIGHTNESS
DISP
* D641
SOURCE
/PWR
LW812-001A-X
BACK LIGHT
S609
* D639
BACK
D655
S610
R607
820
* D637
BACK
2.4V
S8
EJECT
1.2k
1.8k
S611
R608
* D635
F.SKIP
POWER/SRC
R659
2.7k
3.9K
R609
R610
R611
UP
S601
(1/8W)
10K
R617
B-SKIP
S602
R658
R618
F-SKIP
S603
(1/8W)
DOWN
S604
* D633
DOWN
C603
S605
* D631
EQ
C604
* D628
MENU
*
2.4V
RKZ5.1B2KG-X
*
2.4V
SML-D12V8W-X
EJECT
2.4V
* D646
1
S7
* D653
DISP
S6
* D650
4
2.4V
* D648
3
S5
* D644
VOL
2.4V
* D642
VOL
S4
* D658
VOL
2.4V
* D656
VOL
2.4V
* D640
SOURCE
/PWR
2.4V
* D638
BACK
S3
* D636
BACK
S2
* D634
B.SKIP
S1
* D632
UP
1K
* D630
EQ
R664
* D627
MENU
0.1
* D629
MENU
0.1
KEY0
C664
820
NAF0029-001X
C663
R601
820
R661
R602
1.2k
(1/8W)
R603
1.8k
D661
R604
2.7k
R660
(1/8W)
R605
To ELECTRIC UNIT-1
CN701
16
USB5V
KEY0
2.4V
13
14
15
D-
KEY MATRIC
7
8
VOL1
COM
6
S612
1
S601~S617: NSW0246-001X
NOTES
Remote Sensor Circuit
MODELS
1. VOLTAGES ARE DC-MEASURED WITH A DIGITAL VOLT METER WITHOUT INPUT SIGNAL
FOR J/U/E VERSIONS
(WITH IC681)
FOR EE VERSION
(WITHOUT IC681)
LIGHTING TABLE
MODELS
R660
470
330
R661
470
-
C662
1U
0.1 U
D627 - D641
D646 - D651
D653 - D654
D658 - D659
R638,R640
MODELS
D656,D657
Q632
COLLECTOR VOLTAGE
Q632
BASE VOLTAGE
IC661 P2
R654
FOR J/U VERSIONS
FOR E/EE VERSIONS
KD-R432E SERIES
KD-R435U SERIES
2.
KD-R531E SERIES
KD-R437EE
R624,R626,R628
R630,R632,R634
R636,R656
5% METAL GLAZE RESISTOR.
ALL CAPACITORS ARE 50V OR 25V CERAMIC CAPACITOR.
ALL RESISTANCE VALUES ARE IN OHM.
SML-D12V8W-X
(RED)
NOT USED
SML-D12V8W-X
470
SML-311WT-X
(YELLOW AMBER)
NOT USED
SML-311WT-X
470
470
470
SML-D12P8W-X
(GREEN)
SML-D12P8W-X
470
KLB-16B-X
(BLUE)
(GREEN)
NOT USED
ALL CAPACITANCE VALUES ARE IN uF(P=pF)
ALL E.CAPACITORS ARE SHOWN IN THE FORM OF CAPACITANCE(uF)/RATED VOLTAGE(V)
T --- TANTAL CAPACITOR.
NOT USED
KLB-16B-X
820
470
820
0.3V
2.2V
R622,R642
R644,R646
470
470
470
430
0.85V
0.7V
R658
R659
1.5K
1K
1.5K
1K
1.5K
1K
3.3K
2.2K
5.1V
UNLESS OTHERWISE SPECIFIED.
ALL RESISTORS ARE 1/16W
KD-R48EE
D642,D643,D644,D645
Transistor Voltage
KD-R431E SERIES,KD-R430J
KD-R436U SERIES,KD-R434UI
KD-R54J
3.
COMPONENTS IN ( ) INDICATE NOT USE.
4.1V
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)6/13
CD PLAYER UNIT
PICKUP A'SSY
OPTIMA-727A
(QAL0993-001)
LVB11141-A1
SL1
5
4
3
2
1
HDU-120
VF2
6
7
8
Vcc
VT2
GND
9 10
VT1
Vc
1
VF1
0.1
0.1
1k
VR
MD
GND
LD
FOCUSFOCUS+
TRACKING+
TRACKING-
TRACKING COIL
FOCUSING COIL
CN102
QGF0522F3-15W
1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
SPINDLE
MOTOR
VF2
VF2
Vcc
VCC
VT2
VT2
GND
VT1
VT1
Vc
VC
VF1
B1
0
VR
R1
130
MD
VF1
MD
GND
LD
LD
FOCUS-
FO-
FOCUS+
FO+
TRACKING+
TR+
TRACKING-
TR-
SP+
SP+
SP-
SP-
CN101
QGF1044F2-26X
LVB11141-A2
FO+
FO-
SW4
NSW0291-001X
TR+
REST
REST SW
REST
TR-
MGND
LD
FEFE+
SPFE+
FE+
FE-
FE-
SP+
SL2
FEED
MOTOR
LO+
LO-
MD
LOAD
LO+
LO+
LO-
LO-
VC
VT1
REST
MOTOR
VT2
SW1
SW1
VF2
SW2
SW1
VCC
NSW0291-001X
SW3
VF1
1
FOCUS+
2
FOCUS-
3
TRACKING+
4
TRACKING-
5
GND
6
LD
7
GND
8
FEED-
9
FEED+
10
SPINDLE-
11
SPINDLE+
12
LOADING+
13
LOADING-
14
(OPEN)
15
MGND
16
MD
17
Vc(VREF)
18
VT1
19
REST
20
VT2
21
SW1
22
VF2
23
SW2
24
Vcc
25
SW3
26
VF1
To ELECTRIC UNIT-2
CN502
SW2
NSW0291-001X
SW2
SW3
SW3
NSW0291-001X
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)7/13
ELECTRIC UNIT
B911
B910
B925
B908
C310
J1
C330
C251
C252
C320
C340
C304
B311
B192
C301
B552
B178
C172
B912
L5
B172
B191
B102
B784
B551
L4
X1
B105
B538
B777
C162
B4
B5
B176
C24
B169
B792
B503
B315
B175
B103
B186
B106
B783
B766
B173
B168
B774
B189
B536
B190
B543
B772
B167
B542
B174
B907
B917
B165
B104
B10
B924
B789
B787
L6
C160
B775
B185
C704
B913
B916
C881
B761
B2
B915
B171
C932
C913
C904
B164
B182
C302
C906
IC901
N
N
C903
B188
B163
B788
B781
B116
B304
C303
B528
B904
B902
B903
C907
B305
N
B900
B251
B1
B303
N
B308
IC301
B302
B906
1
B6
C350
B306
L901
B920
B307
C309
CN901
B933
J321
D901
B901
C910
B919
B115
1
B921
B918
R901
J120
R902
C901
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
B537
C174
B905
B790
B111
B540
B114
B184
X540
B310
B107
C514
B108
CN502
B183
C591
C590
B181
B180
C586
C584
S701
B110
CN701
B762
B794
B527
B187
B170
B3
B767
B768
B773
B780
B779
B533
B535
B791
X702
B100
B109
B765
B113
B529
B914
X701
L981
S1A
C963
B112
UL MARK
B166
B782
B909
B531
B760
B301
B101
B177
PbF
A
B532
B763
B179
B539
GEA10316-
B534
B776
B764
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)8/13
ELECTRIC UNIT
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
R902
BACKUP
D941
R132
C132
REMOTE
D120
C368
L901
R306
1
R351
D130
R130
IC901
C911
R121
R122
R131
C907
R450
D111
R908
R909
R907
C904
R893
R894
Q952
C891
R415
R785
R772
R725
R405
R720
R706
R702
IC702
Q951
C736
C903
C912
R406
R454
R770
R774
R758
R423
N
C715
R762
R768
R987
R724
R476
R732
R763
L982
R465
C717
R438
R761
N
C986
L703
R722
C989
C985
R984
C990
R488
R740
R741
R986
R982
L981
C724
1
IC981
R462
C733
C730
R445
C734
C707
C720
R786
C708
R983
R962
C963
R448
C981
C987
R449
C983
R981
C722
C732
R752
C718
R721
R782
R965
X701
C728
L702
C725
R446
R745
D981
I
X702
C701
C984
C713
C702
R750
R749
R464
R765
R767
C729
R442
C721
D110
R712
R746
RST
R479
D100
D101
C915
R420
C905
C913
R409
R904
C933
IC931
C932
C931
C703
C954
TXM
R453
C726
R518
E
R112
R501
D891
R444
RXM
R715
DET
R892
R891
R733
E
D
C112
C501
GEB10316A
C503
R519
C906
R428
C122
C131
C731
C704
L701
R883
R481
R747
VDD
ACC
TM
C737
R466
SWDIO
R469
C533
R452
IC531
R482
R463
C532
R510
R102
R100
R502
R110
R503
T1A
R751
C80
C506
R581
C585
R735
R736
R82
D
R111
R101
C100
C110
R598
1
IC501
C505
R460
C510
C508
C584
R593
H
1
L531
C512
R595
C881
Q881
C723
R754
R467
R431
R400
R516
R514
C507
R728
R596
R404
C594
R582
R584
C588
C582
C509
R597
R703
C712
R435
C586
C591
R583
C590
R589
R490
1
C511
1
R477
R738
C714
R744
IC701
CN502
C583
ILL11.5V
R418
IC80
R731
C738
R555
C514
C513
R451
R594
R413
X540
L562
C561
SWCLK
R554
R458
R437
R550
R560
R559
L561
R557
C
C593
C516
R419
R461
R764
R556
R558
C592
R421
GND
R726
C565
R403
D540
R575
R951
R561
C562
R588
R590
R952
C
C564
1
C914
R412
R434
D781
IC530
R530
C531
R794
F
IC540
R553
C595
C120
C941
C908
R757
R708
R713
R771
R440
R975
R973
R971
Q971
R495
D783
Q970
R417
Q782
D780
Q781
Q780
R572
R571
R410
R455
R430
R579
R777
R766
C716
R759
R789
R790
C705
R468
C305
C301
C302
C306
R365
R366
R439
IC532
C535
1
R408
CD8V
L11
C504
C121
SN
R534
L12
R548
R587
BU
R723
R512
C530
DET
C546
R517
R505
C534
C794
C573
C574
C551
Q540
R599
C909
D902
D502
R471
R881
C559
C558
R474
R906
C902
D971
R974
R753
VREF
R506
R508
R513
R511
R507
R504
C553
C552
R549
C555
C557
C556
J
R882
ARF
C544
C545
C547
C549
C548
C910
R302
C321
C341
R342
R257
R322
R168
R169
C172
R976
D970
IC771
C550
R546
R547
C554
R576
R577
C575
C576
R402
R739
R545
R727
R568
R567
R569
R429
R414
R564
R563
R562
R425
C566
R565
L565
L564
L563
C174
F
R459
R570
R509
C587
P1A
H
R472
C568
C543
R540
C540
C542
C541
SDA
C569
C567
C570
C571
C20
R573
C572
R574
C177
C173
C161
C13
C24
R10
L8
C1
L3
R1
C29
R566
R9
L10
C28
R592
R773
R730
L161
X1
C14
C15
C4
C7
L7
C162
R783
R160
R152
A9V
R151
R150
R7
R161
C11
R3
C3
L2
IC161
SCL
C23
IC580
I
R411
1
1
L4
C26
R485
R779
R778
R6
C21
R12
K
R784
C727
R970
R475
R163
C8
R167
IC1
1
C253
R258
C304
R357
R165
L6
C22
C130
R776
R743
R972
R361
C319
C168
C166
Q321
R320
R162
C171
R323
C18
C19
C12
C16
R4
C10
L1
C5
C2
R340
R358
R760
R8
L9
C27
L
R372
C6
R2
R362
C160
L5
C17
R742
C307
C169
R324
R120
D704
VDD5V
C308
C170
R333
R775
R457
C340
R426
R788
C735
R737
R432
R718
R364
C317
R341
R401
R334
D321
K
D121
R367
C318
C320
C252
C316
R447
R363
R456
R253
D251
C251
D1
R303
R347
D341
R349
J1
R255
L
C303
A
R331
R335
R256
M
R368
R321
Q251
R441
C350
A
C330
R304
R254
R251
R252
C309
C254
C331
R332
M
B
J
D901
IC301
C313
R701
C310
R373
B
R901
R307
C315
C901
C312
C311
R310
C351
F101
R352
D131
CN901
C942
D942
R781
C314
J321
J120
R443
R780
REMO
D782
Q341
R350
R330
C851
R851
D852
D851
R941
R470
C111
C102
C101
C706
S701
USB5V
CN701
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)9/13
SWITCH UNIT
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
D652
D631
S611
R639
CN603
D655
D658
D659
R641
R640
D6
44
JS601
45
D6
D638
DI1
S1A
D647
R622
R623
D639
J601
F1A
D657
R642
R643
S608
D636
A
R656
R608
R607
D640
R655
R654
D641
R609
D637
S601
R604
R605
S605
GEA10318-
IC681
D6
R603
R602
R601
D634
S604
D635
42
S603
D656
D6
S607
43
D632
R649
R648
R657
R638
D627
S602
D633
R618
D629
R617
S606
D630
D628
S609
S612
R610
R612
D646
D649
S613
R613
R614
S614
D648
D650
No.MA503
R616
R615
S615
S616
R611
S617
D651
D654
S610
D653
created date:2012-03-22
(No.MA503<Rev.003>)10/13
SWITCH UNIT
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
T1A
IC681
R677
C680
C679
R667
R666
R665
R626
R630
R631
R628
R636
CN601
R629
R634
R635
R637
R632
R633
D664
GEB10318A
C664
R664
D662
R662
C662
C661
C663
R663
R645
R644
R647
R646
C671
R671
L673
C603
C604
C601
R676
R651
Q632
R672
Q631
L674
R624
R625
1
R681
L670
R675
C692
R650
D660
D661
J601
Q633
C602
IC661
R620
R621
C672
R652
R660
C691
R691
R661
D663
CN603
D691
D692
C665
C682
LF691
R678
JS601
R627
PbF
D681
R658
R659
P1A
UL MARK
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)11/13
CD PLAYER UNIT-1
A1
SL1
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
B1
1B
1R
LVA11141-
20
C
1N
CN102
P2A
R1
101NC
SW3
CN101
3 WS
SP-
PbF
FE+
BLK
SP+
UL MARK
YEL
REST
MGND
RED
WHT
FE-
ORG
ORG
SW2
LOLO+
SW1
WHT
YEL
2 WS
1WS
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)12/13
CD PLAYER UNIT-2
(Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade))
(Lead free solder used in the board (material : Sn-Cu, melting point : 230 Centigrade))
P2A
PbF
SW4
SW4
LVA11141-A2
No.MA503
created date:2012-03-22
(No.MA503<Rev.003>)13/13