Mexican Beetle Circuit Diagram (3)

Mexican Beetle Circuit Diagrams Translation
Contents
Models 1998 on
Page
Fuel Injection System - Digifant - ACD Engines manufactured after October 1998
Battery, Starter Motor, Alternator and Voltage Regulator
Ignition and Starter Switch
Digifant Control Unit, Ignition Transformor, Final Stage of Ignition Transformer
Digifant Control Unit, Hall Sensor, Air Temperator and Air Flow Sensor, Engine Temperature Sensor
Digifant Control Unit, Lambda Sensor, Throttle Butterfly Potentiometer, Idle Speed Valve
Digifant Control Unit, Fuel Injectors
Fuel Pump, Fuel Pump Relay, Digifant Control Unit Relay
10/1
10/2
10/3
10/4
10/5
10/6
10/7
10/8
Dual Circuit Brakes - after October 1998
Brake light switch
Rear Brake Lights and Brake Fluid Level Warning Indicator
11/1
11/2
11/3
Conventional (key) Alarm System - after October 1998
Battery
Alarm System Control Unit
Alarm System - Front Flashing Sidelights
Alarm System - Rear Flashing Lights
12/1
12/2
12/3
12/4
12/5
Immobiliser Control Unit via a Digital (encoded) Key
Battery
Immobiliser Control Unit, Anti-Theft Protection, Immobiliser Status
13/1
13/2
13/3
Basic Equipment
Battery, Starter Motor, Alternator, Voltage Regulator
Starter and Ignition Switch, Reverse Gear Lights Switch
Instrument Panel
Instrument Panel, Brake Light Switch, Fuel Gauge Sender, Oil Pressure Sensor
Rear Indicators, Reverse Gear Lights, Rear Lights and Brake Lights
Courtesy Light and Courtesy Light Swtiches
Headlight Dip/Beam and Indicators Switch
Sidelights/Headlight Switch and Horn Switch
Front Headlights and Sidelights
Intermittant Windscreen Wipers Switch, Windscreen Wipers Motor, Windscreen Washer Pump
14/1
14/2
14/3
14/4
14/5
14/6
14/7
14/8
14/9
14/10
14/11
Wiring Diagrams Translation:Fuse Colour Codes:8A = White
Relays:16A = Red
25A = Blue
J17 - Fuel Pump Relay - Relay 80
J176 - Digifant Control Unit Relay - Relay 30
NOTES:
The numbers in qoutes indicate the terminal number
written on the relay.
Relays 30 and 80 are located behind the instrument panel
next to the fusebox
Wiring Colour Codes:-
Relays in Fusebox:-
ws = White
sw = Black
ro = Red
br = Brown
gn = Green
NOTE: The relays below are numbered from left to right
bl = Blue
gr = Grey
li = Purple
ge = Yellow
1. Indicators Relay
2. Not used
3. Alarm System
4. Intermittant Windscreen Wipers
Wiring Symbols and Terminals Letters:Symbol / Terminal
Description
A
B
C
C1
D
E1
E2
E3
E4
E20
E22
E75
F
F2
F3
F4
F120
F266
G
G1
G10
G23
G27
G39
G40
G42
G88
H
H1
H8
J2
J17
J31
J85
J169
J176
J362
K
K1
K2
K3
K5
K6
K7
K115
L1
L2
L9
L10
M6
M8
M16
M17
M21
M22
M35
M36
Battery
Starter Motor
Alternator
Voltage Regulator
Starter and Ignition Switch
Lights Switch
Indicators Switch
Hazzard Warning Lights Switch
Headlight Dip/Beam Switch
Instrument Panel Lights Dimmer
Windscreen Wipers Switch
Alarm System Switch
Brake Lights Switch
Courtesy Light Door Switch - Left
Courtesy Light Door Switch - Right
Reverse Gear Lights Switch
Front Boot Alarm Switch
Rear Engine Cover Alarm Switch
Fuel Gauge Sender
Fuel Gauge
Low Oil Pressure Switch
Fuel Pump
Engine Temperature Sensor
Lamda Sensor
Hall Sensor
Air Temperature and Air Flow Sensor
Throttle Butterfly Potentiometer
Horn Switch
Horn / Dual Tone Horn
Alarm Activated Siren
Indicators Relay
Fuel Pump Relay
Intermittant Windscreen Wipers Relay
Alarm System Control Unit
Digifant Control Unit (Engine Management)
Digifant Control Unit Power Relay (via terminal 30)
Immobiliser Control Unit
Instrument Panel Lights (Headlights Switch ?)
High Beam Warning Light
Alternator Warning Light
Oil Pressure Warning Light
Indicators Warning Light
Hazzard Lights Warning Light
Dual Braking Circuit and Handbrake Warning Light
Immobiliser Actived Light
Front Left Headlight (Dip and Beam)
Front Right Headlight (Dip and Beam)
Courtesy Door Light and Courtesy Door Light's Switch
Instrument Panel Illumination Lights
Rear Indicator - Left
Rear Indicator - Right
Reverse Gear Light - Left
Reverse Gear Light - Right
Rear Left Brake and Rear Lights
Rear Right Brake and Read Lights
Front Indicator - Left
Front Indicator - Right
Location (if applicable)
Part of Alternator
Symbol / Terminal
Description
N14
N30
N31
N32
N33
N71
N80
N152
N157
O
P
Q
S1
S2
S3
S4
S5
S6
S7
S8
S9
S10
S11
S12
S81
T1a
T1b
T1c
T1d
T1e
T1g
T1h
T2
T2a
T2c
T2d
T2e
T2f
T2g
T2h
T3
T3a
T3b
T4
T5a
T5b
T5c
T6
T6a
T7
T8
T8a
T8b
T8c
T10
T25
T28
V
V36
W16
X
Dual Circuit Braking - Electronic Device Connection
Cylinder 1 Injector
Cylinder 2 Injector
Cylinder 3 Injector
Cylinder 4 Injector
Idle speed stabilization valve
Electronic valve for the Active Carbon Filter
Ignition Transformer
Ingition Coil Transformer - Final Stage
Distributor
Spark Plug Covers
Spark Plugs
Fuel Pump Fuse
Black 1 pin Connector
Black 1 pin Connector
Black 1 pin Connector
Black 1 pin Connector
Red 1 pin Connector
White 1 pin Connector
White 1 pin Connector
Grey 2 pin Connector
White 2 pin Connector
Black 2 pin Connector
Red 2 pin Connector
Black 2 pin Connector
Back 2 pin Connector
White 2 pin Connector
Black 2 pin Connector
Black 3 pin Connector - Diagnostics Socket
Black 3 pin Connector
3 pin Connector
Black 4 pin Connector
Black 5 pin Connector
Black 5 pin Connector
Black 5 pin Connector
6 pin Connector
6 pin Connector
Black 7 pin Connector
Black 8 pin Connector
Black 8 pin Connector
White 8 pin Connector
Black 8 pin Connector
White 10 pin Connector
25 pin Connector
28 pin Connector (Round)
Wiper Motor
Fuel Pump
Courtesy Light
Number Plate Light
Location (if applicable)
Underneath Rear Seat, Left Hand Side
Underneath Rear Seat, Left Hand Side
Behind the Instrument Cluster
Behind the Instrument Cluster
Engine Compartment
Engine Compartment - Centre
Behind the Instrument Cluster
Behind the Instrument Cluster
Front Boot
Front Boot, Left Hand Side
Engine Compartment, Left Hand Side
Engine Compartment
Engine Compartment
Steering Column
Behind the Instrument Cluster
Behind the Instrument Cluster
Steering Column
Behind the Dashboard
Behind the Instrument Cluster - Centre
Behind the Instrument Cluster - Centre
Steering Column
Underneath Rear Seat, Left Hand Side
Underneath Rear Seat, Left Hand Side
Engine Compartment, Left Hand Side
Symbol / Terminal
Circled Numbers
30
39
40
42
74
81
94
110
199
A2
A40
A17
A20
A24
A32
A40
A61
A89
A99
A138
A157
A158
A159
B102
B108
B109
B131
B143
B146
B158
B169
B239
G3
G4
G6
D132
Description
Location (if applicable)
Connection point
Connection point
Connection point
Connection point
Connection point
Connection point 1
Connection point 1
Connection point 2
Connection point 3
Positive Connection - Terminal 15
Positive Connection - Terminal 58b
Terminal 61
Terminal 15a
Braking System Connection
Positive Connection - Terminal 30
Positive Connection - Terminal 30
Positive Connection - X
Connection Point 2 - Terminal 54
Connection Point 1 - Terminal 87
Connection Point 2
Terminal 49a
Terminal T
Terminal L
Connection point
Connection point
Connection point
Terminal 54
Positive Connection - Terminal 54
and Terminal 58R (Positive)
Conneciton point 1 - Terminal 87
Connection - Terminal S
Terminal 30 (+ Battery)
Positive Connection - Terminal 50
Positive Connection
Negative Connection
Positive Connection - Terminal 15
Terminal RF
Next to relay plate
Underneath Rear Seat - Left Hand Side
Underneath Rear Seat - Centre (?)
Next to Steering Column
Inside the head-lining
Instrument Cluster Wiring Harness
In Digifant's Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Wiring loom behind the instrument cluster
Connection Point - Behind Instrument Cluster
Behind Instrument Cluster
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Behind Instrument Cluster
Behind Instrument Cluster
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Instrument Cluster Wiring Harness
Interior - Front Left
Interior - Rear Right (?)
Interior Wiring Harness - Rear Left
Interior Wiring Harness
Interior Wiring Harness
Interiior Wiring Harness
Interiior Wiring Harness
Interior - Wiring Harness
Connection Point - Interior
Fuel Injection Cables
Fuel Injection Cables
Digifant ECU's Wiring Harness
Engine bay wiring harness