Service Manual - Mandos a Distancia

Transcription

DVD Portable Player
PET830
All version
Service Manual
TABLE OF CONTENTS
Chapter
Technical Specification & Service Tips…………..……….. 1
Safety Instructions…………………………………………….. 2
Instruction for Use……………………………………………… 3
Mechanical Instructions………………………………………. 4
Troubleshooting …………………………………………………5
Overall Block Diagram…………………………………………. 6
Electrical Diagram……………………………………………… 7
Exploded View Diagram & Service Part List………………. 8
Revision List……………………………………………………. 9
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may by reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronics,
mechanical, photocopying, or otherwise without the prior permission of Philips
3141 785 31570
Version 1.0
1.0 TECHNICAL SPECIFICATION
Playback disc type:
DVD, Picture-CD,
SVCD, Video CD, MP3CD, CD-R/CD-RW,
WMA-CD, DVD-R, DVDRW, DVD+R, DVD+RW
Video Playback Format:
DVD / VCD / JPEG /
MPEG4 / DIVX3,4,5,6
1.2Vrms typical
0.03% typical
>80dB
>80dB
+1dB/-0.5
Audio Playback Format:
CD/MP3, MP3-DVD,
WMA
Disc Diameter
12cm
>=85dB
1dB
Pixel specification
General
Dimensions (W x H x D):
Weight:
Power supply:
Power consumption:
Operating temp. & RH:
Audio System
Output voltage 1kHz:
THD 20-20kHz (%):
Dynamic range:
Signal/Noise ratio:
Frequency response (2020kHz):
Channel Separation 1kHz
Channel Balance 1kHz
255 x 170 x 31 mm
0.97kg
100 – 240V (AC adaptor)
DC 12V (Battery)
24W
0 – 45 degC / 30 – 90% RH
Zero bright-dot & max. 3 dark-dots
Current consumption
Factory Service Mode (FSM)
DC-IN SUPPLY (9V)
Standby Power off
5mA
BATT. SUPPLY
Voltage
7.4V
Capacity
2600mAH
Battery playtime
3 hour
Charging time
<4.0 hour
Standby Power off
<300uA
Headphone out (headphone output load 2x16 ohm)
Maximum output power:
Frequency response:
SNR (A-wght):
THD (0.2-20kHz):
Left-Right Channel
Separation:
Left-Right Channel
Balance:
To check the software version and change
region code of your DVD Portable.
1. Press “
” (STOP/EJECT) on the main set
2. Press “ ” (PLAY/PAUSE) on the main se
3. Press “1” -> “4” -> “0” -> “0” by remote control
4. The screen is under “FSM MENU”
” to select “VERSION”,
5. Press “
“REGION”, “AGING” and “FUNCTION”
10mW
+/-3dB
>80dB
0.2% typical
>55dB
<1dB
Supported disc type
Video Playback
Formats:
6.
Refer below table for your region code setting
7.
8.
Press “
” to save your setting
Press “SETUP” to exit
Audio Playback
Formats:
1.0 TECHNICAL SPECIFICATION
Procedure on how to upgrade the software of
the DVD Portable
For the best performance of your DVD Portable.
Check www.philips.com/support for latest
software upgrades available.
A) PANEL firmware upgrade
1. Unzip the WDR830.ROM
2. Drag-n-drop to USB drive
3. Power on PET830 with AC/DC adaptor
4. Insert USB drive to the USB port of the main set
5. The set will detect the updated firmware
6. Press “OK” to confirm and proceed
Warning: Do not unplug the AC adaptor during
firmware upgrade to prevent flash corrupt of the
set!!
B) DVD firmware upgrade
7. Unzip the WDR830.ROM (different file from step 1)
8. Drag-n-drop to USB drive
9. Power on PET830 with AC/DC adaptor
10. Insert USB drive to the USB port of the main set
11. The set will detect the updated firmware
12. Press “OK” to confirm and proceed
Warning: Do not unplug the AC adaptor during
firmware upgrade to prevent flash corrupt of the
set!!
2.0 SAFTETY INSTRUCTIONS
GB
NL
ESD
WARNING
Alle IC’s en vele andere halfgeleiders zijn
gevoelig voor electrostatische ontladingen
(ESD).
Onzorgvuldig behandelen tijdens reparatie kan
de levensduur drastisch doen verminderen.
Zorg ervoor dat u tijdens reparatie via een
polsband met weerstand verbonden bent met
hetzelfde potentiaal als de massa van het
apparaat.
Houd componenten en hulpmiddelen ook op
ditzelfde potentiaal.
All ICs and many other semi-conductors are
susceptible to electrostatic discharges (ESD).
Careless handling during repair can reduce life
drastically.
When repairing, make sure that you are
connected with the same potential as the mass
of the set via a wrist wrap with resistance.
Keep components and tools also at this
potential.
F
WAARSCHUWING
ATTENTION
I
Tous les IC et beaucoup d’autres
semi-conducteurs sont sensibles aux
décharges statiques (ESD).
Leur longévité pourrait être considérablement
écourtée par le fait qu’aucune précaution n’est
prise à leur manipulation.
Lors de réparations, s’assurer de bien être relié
au même potentiel que la masse de l’appareil et
enfiler le bracelet serti d’une résistance de
sécurité.
Veiller à ce que les composants ainsi que les
outils que l’on utilise soient également à ce
potentiel.
D
AVVERTIMENTO
WARNUNG
Alle ICs und viele andere Halbleiter sind
empfindlich gegenüber elektrostatischen
Entladungen (ESD).
Unsorgfältige Behandlung im Reparaturfall kan
die Lebensdauer drastisch reduzieren.
Veranlassen Sie, dass Sie im Reparaturfall über
ein Pulsarmband mit Widerstand verbunden
sind mit dem gleichen Potential wie die Masse
des Gerätes.
Bauteile und Hilfsmittel auch auf dieses gleiche
Potential halten.
Tutti IC e parecchi semi-conduttori sono
sensibili alle scariche statiche (ESD).
La loro longevità potrebbe essere fortemente
ridatta in caso di non osservazione della più
grande cauzione alla loro manipolazione.
Durante le riparazioni occorre quindi essere
collegato allo stesso potenziale che quello della
massa dell’apparecchio tramite un braccialetto
a resistenza.
Assicurarsi che i componenti e anche gli utensili
con quali si lavora siano anche a questo
potenziale.
GB
Safety regulations require that the set be restored to its original
condition and that parts which are identical with those specified,
be used.
“Pour votre sécurité, ces documents
doivent être utilisés par des spécialistes agréés, seuls habilités à réparer
votre appareil en panne”.
NL
Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie in
zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,
identiek aan de gespecificeerde, worden toegepast.
CLASS 1
LASER PRODUCT
3122 110 03420
F
Les normes de sécurité exigent que l’appareil soit remis à l’état
d’origine et que soient utiliséés les piéces de rechange identiques
à celles spécifiées.
GB
Warning !
Invisible laser radiation when open.
Avoid direct exposure to beam.
D
Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu
beachten. Der Original zustand des Geräts darf nicht verändert werden;
für Reparaturen sind Original-Ersatzteile zu verwenden.
S
Varning !
Osynlig laserstrålning när apparaten är öppnad och spärren
är urkopplad. Betrakta ej strålen.
SF Varoitus !
I
Le norme di sicurezza esigono che l’apparecchio venga rimesso
nelle condizioni originali e che siano utilizzati i pezzi di ricambio
identici a quelli specificati.
Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina
näkymättömälle laserisäteilylle. Älä katso säteeseen!
DK Advarse !
"After servicing and before returning set to customer perform a
leakage current measurement test from all exposed metal parts to
earth ground to assure no shock hazard exist. The leakage current
must not exceed 0.5mA."
Usynlig laserstråling ved åbning når sikkerhedsafbrydere er
ude af funktion. Undgå udsaettelse for stråling.
2.1 ESD PROTECTION
Whenthepowersupplyisbeingturnedon,youmaynotremovethislasercautionslabel.Ifitremoves,radiationoflaser
maybereceived.
PREPARATIONOFSERVICING
PickupHeadconsistsofalaserdiodethatisverysusceptibletoexternalstaticelectrocity.
Althoughitoperatesproperlyafterreplacement,ifitwassubjecttoelectrostaticdischargeduringreplacement,
itslifemightbeshortened.Whenreplacing,useaconductivemat,solderingironwithgroundwire,etc.to
protectthelaserdiodeformdamagebystaticelectricity.
Andalso,theLSIandICaresameasabove.
Groundconductive
wriststrapforbody.
Solderingiron
withgroundwire
orceramictype
1M
Conductivemat
Thegroundresistance
betweenthegroundline
andthegroundislessthan10
SAFTY NOTICE
SAFTY PRECAUTIONS
LEAKAGE CURRENT CHECK
Plug the AC line cord directly into a 120V AC outlet (do
not use an isolation transformer for this check). Use an
AC voltmeter, having 5000 per volt or more sensitivity.
Connect a 1500 10W resistor,paralleled by a 0.15uF
150V AC capacitor between a knomn good earth ground
(water pipe, conduit, etc.) and all exposed metal parts of
cabinet (antennas, handle bracket, metal cabinet
screwheads, metal overlays, control shafts, etc.).
Measure the AC voltage across the 1500 resistor.
The test must be conducted with the AC switch on and
then repeated with the AC switch off. The AC voltage
indicated by the meter may not exceed 0.3V.A reading
exceeding 0.3V indicates that a dangerous potential
exists, the fault must be located and corrected.
Repeat the above test with the DVD VIDEO PLAYER
power plug reversed.
NEVER RETURN A DVD VIDEO PLAYER TO THE
CUSTOMER WITHOUT TAKING NECESSARY
CORRECTIVE ACTION.
READING SHOULD NOT EXCEED 0.3V
AC VOLTMETER
DVD VIDEO PLAYER
(5000 per volt
or more sensitivity)
1500
10W
AC OUTLET
Good earth ground
such as a water pipe,
conduit, etc.
0.15uF 150V AC
Test all exposed metal.
Voltmeter Hook-up for Leakage Current Check
The lightning flash with arrowhead symbol, within an
equilateral triangle, is intended to alert the user to the
presence of uninsulated "dangerous voltage" within the
product's enclosure that may be of sufficient magnitude to
constitute a risk of electric shock to persons.
The exclamation point within an equilateral triangle is
intended to alert the user to the presence of important
operating and maintenance (servicing) instructions in the
literature accompanying the appliance.
3.0 INSTRUCTION FOR USE
4.0 MECHANICAL INSTRUCTION
Disassembly Procedure on PET830
Spare Parts
1
Remove five screws on
back cabinet to separate
top cabinet and back
cabinet.
2
Generally open the front
cabinet.
3
Disassemble FPC from
turn board on top cabinet.
4
Disassemble connecter of
speaker from main board.
(5pcs)
5
After 3 and 4 procedures,
we will get top cabinet
assembly and back
cabinet assembly.
6
Remove three conductive
fabrics.
7
Disassemble FPC of TFTLCD from turn board.
(3pcs)
8
Remove six screws on
turn board and jogging
board. Disassemble
connecter of TFT-LCD
from turn board.
(6pcs)
9
Remove two screws on
eject board.
(2pcs)
10
Remove all PCB boards
on top cabinet. Remove
six screws on speaker,
and then remove
speaker.
(6pcs)
11
Remove six screws and
sponges on TFT-LCD.
(6pcs)
(6pcs)
12
Remove TFT-LCD and
disassembly of top
cabinet is ok.
13
Remove four screws on
driver and FFC of driver
from main board.
14
Remove top keypad
board from back cabinet,
and disassemble FFC
from main board.
(4pcs)
15
Remove four screws on
main board.
(4pcs)
16
Remove six screws on
plate metal EMI.
(6pcs)
17
Remove two screws on
PCB of battery.
(2pcs)
18
Use tool to remove
battery from back cabinet.
19
Finally, we will get the
back cabinet.
5.0 TROUBLESHOOTING
SYMPTOM: BATTERY NO POWER
BATTERY CAN＇T
Power ON
Start
Check Battery capacity?
no
Check charging
function OK?
Check adaptor
power-ON OK?
Yes
yes
SET OK?
Yes
No
Check the Power-ON
button and cable OK?
NO
Replace Button or
Cable
No
Yes
Replace Main Board
No Defect, return
set to Customer
5.0 TROUBLESHOOTING
SYMPTOM: NO IMAGE / NO SOUND
SYMPTOM: NO IMAGE OUTPUT( THE PANEL SHOW BLUE PICTURE
)
Start
Check DVD Drive work?
no
Replace DVD Drive
no
Exchange AV cable
yes
NOTE: AV Cable TYPE from outside to
Inside L-Audio, R-Audio, Video, Ground
Check the external AV
Cable TYPEnote and
connection is OK?
yes
Replace Main Board
SYMPTOM: NO SOUND COMES FROM SPEAKER
Start
Check the Connection OK?
no
Reinsertion
no
Change the speaker
yes
Check speaker OK?
yes
Replace Main Board
5.0 TROUBLESHOOTING
SYMPTOM: THE DVD DRIVE DOES NOT WORK
SYMPTOM: THE DVD DRIVE DOESN
＇T WORK
Start
Check DVD-Loader
connection OK?
NO
Cable Reinsertion
NO
Replace DVDLoader
Yes
Check the DVD-Loader
OK?
Yes
Replace main board
5.0 TROUBLESHOOTING
SYMPTOM: ADAPTOR CANNOT POWER ON
Adaptor can not Power ON
Start
Check Adaptor OK?
NO
Change adaptor
SET OK?
Yes
Yes
No
Check the Power-ON
button and cable OK?
YES
Return set to
Customer
Replace Main Board
NO
Replace Button or
Cable
OK
5.0 TROUBLESHOOTING
SYMPTOM: REMOTE CONTROL CANNOT WORK
SYMPTOM: THE REMOTE CONTROL CAN NOT
WORK
Start
Check CABLE form
bottom board to top board
connection OK?
NO
Cable Reinsertion
NO
Replace IR receiver
Yes
Check TOP-board OK?
NO
Replace top board
OK
Yes
OK
Replace main board
OK
Return to custormer
5.0 TROUBLESHOOTING
SYMPTOM: USB CANNOT WORK
SYMPTOM: THE USB DOESN＇T WORK
Start
Check USB INSERTION
OK?
NO
USB Reinsertion
Yes
PET830 USB current limit Is500mA
Check the external USB
power consumption ?
Yes
Replace main board
SYMPTOM: NO SOUND FROM HEADPHONE
Over spec
Add external adaptor on USB
Or
Change another USB
5.0 TROUBLESHOOTING
SYMPTOM: LED DISPLAY FAILURE
SYMPTOM: LED Display Fail
Start
Check CABLE form Main board to top board
connection OK?
NO
Cable Reinsertion
Yes
Check TOP-board OK?
NO
Replace LED
NO
Replace top board
OK
Yes
OK
Replace main board
OK
Return to custormer
5.0 TROUBLESHOOTING
SYMPTOM: KEY & BOTTON FAILURE
SYMPTOM: Key & Botton Fail
Start
Check CABLE form board to
board connection OK?
NO
Cable Reinsertion
Yes
Check KEY board OK?
NO
OK
Yes
Replace main board
Replace KEY board
OK
Return to custormer
6.0 OVERALL BLOCK DIAGRAM
7.0 ELECTRICAL DIAGRAM
5
J7
PJ-362
L
R
V
G
C226
10P/50V/0402
FB11
R71
FB12
FB14
C222
10P/50V/0402
C220
10P/50V/0402
C225
10P/50V/0402
1A/600OHM/0603
1K/F/0603
1A/600OHM/0603
1A/600OHM/0603
GND_DC
TBD10
NC
1
2
4
5
3
6
7
G
AVIN_LIN (13)
AVINDET-AUX5 (9)
AVIN_RIN (13)
AVIN_CVBS (21)
C46
10P/50V/0402
C53
10P/50V/0402
D
GND_SIGNAL
GND_SIGNAL
TBD11
BCF-35320A
R
V
1
GND_SIGNAL
C50
10P/50V/0402
C58
10P/50V/0402
2
R477
0/J/0603
AVJACKGND
J6
PJ-362
L
3
FB13 1A/600OHM/0603
AVIN-DET
AVIN-DET_GND
AVIN-R
AVIN-CVBS
AVJACKGND
D
A/V INPUT
AVIN-L
1
2
4
5
3
6
7
4
GND_DC
A/V OUTPUT
AVOUT-L
FB10 1A/600OHM/0603
AVOUT-DET
AVOUT-DET_GND
AVOUT-R
AVOUT-CVBS
FB53
R407
FB8
FB9
AVJACKGND
C210
10P/50V/0402
C207
10P/50V/0402
1A/600OHM/0603
1K/F/0603
1A/600OHM/0603
1A/600OHM/0603
C377
C209
10P/50V/0402 10P/50V/0402
R447 75/F/0603
AVOUT_L (14)
AVOUT_DET (9)
GND_SIGNAL
R64
NC
R448 75/F/0603
C38
10P/50V/0402
C378
10P/50V/0402
AVOUT_R (14)
AVOUT_CVBS (26)
C42
10P/50V/0402
C
C
GNDV
ISOLATOR
GND_SIGNAL
HP2 OUT
1
J4
PJ-328
3
5
4
2
1
TP33
1
HP2-DET
TP1
FB7
1A/600OHM/0603
HP2_DET (13)
HPGND
C194
10P/50V/0402
HP1
OUT
J2
PJ-328
3
5
4
2
1
1
1
TP20
C20
10P/50V/0402
TP2
HPLOUT
HP1-DET
FB1
FB3
GND_SIGNAL
1A/600OHM/0603
1A/600OHM/0603
R471 22/F/0603
HPROUT
HPGND
FB4
1A/600OHM/0603
R472 22/F/0603
HP_L_OUT (13)
HP1_DET (13)
HP_R_OUT (13)
B
B
C187
10P/50V/0402
P4
C184
10P/50V/0402
C183
10P/50V/0402
C1
10P/50V/0402
C6
10P/50V/0402
C11
10P/50V/0402
1
TP9
TBD13
NC
1
GND_SIGNAL
TBD14
BCF-35320A
R478
0/J/0603
GND_SIGNAL
GND_DC
ISOLATOR
1
A
J10
PJ-328
TP184
3
5
4
2
1
COAXIAL
A
FB20
1A/600OHM/0603
COAX (14)
C271
100P/50V/0603
C91
100P/50V/0603
1
TP185
Title
Size
A3
GND_DC
AV PORT
Document Number
5
4
3
2
Rev
F
WDR830 SYSTEM BOARD
Date: Wednesday, January 03, 2007
Sheet
1
3
of
28
5
2
R276
0/J/0402
D
+5V_M
1
SW1
SW2
SW3
SW4
VR_CD
3
SW1
SW2
SW3
SW4
W
+5V_RF
R258
0/J/0603
V
OUT_SW
CLOSE
1
TC15
47U/10V/B
R273
10K/F/0402
GND_RF
R277
10K/F/0402
CD_DVD
Q34
PMBS3904
B
R275
0/J/0402
U
V
W
SLED+
SLED-
VR_DVD
D
GNDM
R274
R272
100K/F/0402 10K/F/0402
LOADFOCUS+
TRACKTRACK+
FOCUS-
S
C
G
Q32
PMBS3904
B
C
D
A
RF
F
E
E
B
DVDLD
GND_RF
PVC
GND_RF
GND_RF
DVDMDI
GND_RF
C64 0.1U/25V/0603
V5_RF
E
F
RF
CD_DVD
CDMDI
CDLDO
DVDLDO
FB18
1A/600OHM/0603
C68
0.1U/25V/0603
12mil
CD_DVDCT
+3.3V_SYS
C93
0.1U/25V/0603
C95
0.1U/25V/0603
R145
3.3/F/0603
1
SW1
SW2
SW3
SW4
TC8
100U/6.3V/B
R135
10K/F/0603
2
1A/600OHM/0603
1A/600OHM/0603
1A/600OHM/0603
1A/600OHM/0603
J8
57P/0.5/DOWN/FPC
C408 10P/50V/0402
C409 10P/50V/0402
GND_RF
Q18
2SB1132
C410 10P/50V/0402
R136
680/F/0603
B
CDLDO (9)
C90
1N/25V/0603
C
L2
10UH/50mA/0603
C411 10P/50V/0402
CD_DVDCT (9)
D
C
B
A
CD_DVD
RF
F
E
V5_RF
PVC
1
1
1
1
1
1
1
1
1
1
VR_CD
VR_DVD
R_MDI
1
1
1
TP90
TP92
TP93
TP89
TP88
TP86
TP85
TP84
TP81
TP80
TP79
TP78
TP77
CDLD
ISOLATOR
1
GND_RF
B
1
GNDM
PIN 1
GND_POWER
+3.3V_SYS
L3
10UH/50mA/0603
C85
0.1U/25V/0603
C87
0.1U/25V/0603
R126
1/F/0603
TC5
100U/6.3V/B
R104
10K/F/0603
E
2
(DOWN
CONTACT)
1
V33DVDRF
TOP VIEW
GND_RF
C
Q14
2SB1132
L1
10UH/50mA/0603
B
R105
560/F/0603
DVDLDO (9)
C72
1N/25V/0603
DVDLD
PIN 57
A
FOCUSTRACK+
TRACKFOCUS+
1
1
1
1
VH
HWHW+
HVHV+
HUHU+
VHVCC
U
V
W
SLED+
SLED-
1
1
1
1
1
1
1
1
1
1
1
1
1
OUT_SW
LOAD+
LOADDVDLD
CDLD
SW1
SW2
SW3
SW4
1
1
1
1
1
1
1
1
1
Title
Size
A3
Date:
5
4
C
L4
10UH/50mA/0603
V33CDRF
FB67
FB68
FB69
FB70
FOCUS- (7)
TRACK+ (7)
TRACK- (7)
FOCUS+ (7)
LOAD+ (7)
LOAD- (7)
B
(9)
C
(9)
D
(9)
A
(9)
RF
(9)
F
(9)
E
(9)
PVC (9)
DVDMDI (9)
CDMDI (9)
SVREF (7,9)
RF
(9)
GND_RF
A
D
C
B
D
CDLDO (9)
DVDLDO (9)
PVC
DVDMDI
CDMDI
SVREF
RF
+5V_SYS
(7)
(7)
(7)
(7)
(7)
(7)
(7)
U
(7)
V
(7)
W
(7)
SLED+ (7)
SLED- (7)
FOCUSTRACK+
TRACKFOCUS+
LOAD+
LOAD-
Q31
2SK3018
LOAD+
0/J/0603
VH
HWHW+
HVHV+
HUHU+
+5V_RF
E
CD_DVDCT
R96
OUT_SW (9)
CLOSE (7,9)
VH
HWHW+
HVHV+
HUHU+
C
GNDM
CDLD
R_MDI
VR_DVD
VR_CD
(9)
(9)
(9)
(9)
S
R262
220/J/0603
U
VHVCC
HWHW+
HVHV+
HUHU+
VH
OUT_SW
SLED+
SLED-
Q33
2SK3018
G
2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
E
G1
58
C
3
TopRay + QSI TDR086L SLOT-IN Loader
G2
59
D
A3
A3
A2
A2
A1
A1
VHVCC
H3H3+
H2H2+
H1H1+
VH
OUT_SW
TV+
TVLED
GND
GND
EJECT_SW
NC
MTR+
MTR+
NC
MTRMTRFO+
TRTR+
FONC
LD(DVD)
GND
LD(CD)
MD
VR(DVD)
VR(CD)
GND
VREF
VCC
NC
E
F
RF
SW
NC
A
B
C
D
NC
NC
SW1
SW2
SW3
SW4
4
3
2
TP69
B
TP61
TP74
TP72
TP71
TP70
TP62
TP55
TP56
TP57
TP58
TP59
TP60
TP54
TP53
TP51
TP52
TP64
TP66
TP63
TP67
TP68
TP75
TP76
TP94
TP102
TP113
TP114
A
Connector of Loader
Document Number
Rev
F
WDR830 SYSTEM BOARD
Wednesday, January 03, 2007
Sheet
1
4
of
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
D
D
F5
1206L075
FB15
1A/600OHM/0805
+5V_SYS
1
5V_USB
C61
0.1U/25V/0603
TC2
47U/10V/B
2
C60
0.1U/25V/0603
1
J9
USB-A
VCC 1
D- 2
D+ 3
GND 4
GND_DC
TP73
GND_POWER
C
CK1
L0114S0133DLW31S
2
1
D-_USB
D+_USB
3
R97
33/J/0603USB_N0
R100 33/J/0603USB_P0
4
G2
G1
G1
C
G2
C241
10P/50V/0603
C242
10P/50V/0603
1
C65
10P/50V/0603
GND_POWER
1
R95
15K/F/0603
R101
15K/F/0603
TP83
P7
B
C63
10P/50V/0603
USB_N0 (9)
USB_P0 (9)
GND_POWER
GND_DC
B
ISOLATOR
A
A
Title
CON_USB
Size
A
Document Number
Date:
5
4
3
Rev
F
WDR830 SYSTEM BOARD
2
Sheet
of
5
1
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
J1
D
C
1
1
VT_M 1
2
2
IF-OUT_M
1
3
3
4
4
5
5
6
6
7
7
8
8
TP21
D
TP8
R468 0/J/0402
TUNER_NC
TP18
1
TP31
1
R6 0/J/0402
TUNER_RST
C383 10P/50V/0402
9
9
10
10
TUNER_STR
11
11
12
12
13
13
14
14
15
15
16
16
17
17
TUNER_D4
18
18
TUNER_D5
19
19
20
20
21
21
22
22
23
23
24
24
TUNER_CAMCLK
1
1
1
PWR_TUNER (19)
L:Active
H:OFF
C405 10P/50V/0402
TUNER_FAIL
B
1
TP22
DVB_RST (19)
TP30
C
TP17
TP174
R43
0/J/0603
C35 NC
5.12MHz
CAMCLK (9)
7xx~1.9MHz
1
TP175
TUNER_D0
FLAG[0..7]
TP28
1
C12 10P/50V/0402
TP15
1
C13 10P/50V/0402
TP27
1
C14 10P/50V/0402
TP14
1
C15 10P/50V/0402
TP26
1
C16 10P/50V/0402
TP13
1
C17 10P/50V/0402
TP25
1
C18 10P/50V/0402
TP12
1
C19 10P/50V/0402
TP24
1
C384 10P/50V/0402
TUNER_D1
TUNER_D2
TUNER_D3
TUNER_D6
TUNER_D7
TUNER_SCL
TUNER_SDA
TP11
1
R9
0/J/0402
FLAG0
R10
0/J/0402
FLAG1
R11
0/J/0402
FLAG2
R12
0/J/0402
FLAG3
R13
0/J/0402
FLAG4
R14
0/J/0402
FLAG5
R15
0/J/0402
FLAG6
R16
0/J/0402
FLAG7
R17
0/J/0402
R18
0/J/0402
FLAG[0..7] (9)
B
SCL
(8,9,21)
SDA (8,9,21)
C385 10P/50V/0402
24P/0.5/DOWN/FPC
ISOLATOR
A
A
Title
Size
A
Date:
5
4
3
CON OF NIM Module
Document Number
Rev
F
WDR830 SYSTEM BOARD
2
Sheet
6
of
1
28
A
TRO
FOO
1
1
R233
1K/F/0402
1
33N/50V/0603
6
VO1R
7
PGND1
U10-12
12
VO3R
13
+5V_M
U6
BH5510KV
U10-13
2
1
U10-38
U10-39
U10-40
U10-41
U10-43
U10-42
CNF5
2
37
38
39
CNF4
40
CNF3
42
43
44
45
46
47
41
CNF2
VREF
VO4R
33
1
TP47
VO4F
32
1
TP48
PGND3
31
W
30
RNF2
29
PVCC22
28
V
27
U
26
RNF1
25
VO3F
PVCC21
0/J/0603
34
PVCC1
HB
R67
11
PVCC3
LOAD- (4)
LOAD+ (4)
3
+5V_M
C386
0.1U/25V/0603
GNDM
W
W
V
C206
0.1U/25V/0603
U
TC13
47U/10V/B
R66
0.22/F/0603
GNDM
U10-14
C208
0.1U/25V/0603
(4)
+5V_M
24
(4) SLED+
SLED+
U10-11
1A/600OHM/0603
V
(4)
U
(4)
2
GNDM
C44
0.01U/50V/0603
C43
1N/50V/0402
HW-
HW+
HV-
HV+
HU-
HU+
GNDM
C212
0.1U/25V/0603
U10-23
(4) SLED-
0/J/0603
R48
VO2R
23
10
1A/600OHM/0603
35
VO2F
HWN
9
22
8
FO-
HWP
FO+
0/J/0603
HVN
0/J/0603
R54
BH5510KV
21
R53
FOCUS-
R46
VO5F
1
VO1F
FOCUS+
GNDM
36
2
5
20
TR+
TR-
IN1
0/J/0603
CNF1
0/J/0603
R52
STBY
TC12
47U/10V/B
VO5R
BMSW
4
HVP
R50
3
STBY
HUN
TRACKTRACK+
GVSW
19
56K/F/0402
22K/F/0402
FG
2
IN2
R45
R47
1
IN3
AMPSTBY
SVREF (9)
C198
1U/16V/0603
IN4
47K/F/0402
NC
R65
U10-44
SVREF
47K/F/0402
R42
R44
SLED-
INSP
GNDM
4.7K/J/0402
GNDM
+5V_M
IN5
1
18
(4) FOCUS-
33N/50V/0603
C34
TP46
HUP
(4) FOCUS+
47N/50V/0603
C33
17
(4) TRACK+
C32
VCC
(4) TRACK-
R40 0/J/0603
FG
3.3K/F/0402
(9) AMPSTBY
SLED
16
R243
E
4
GND
GNDM
47N/50V/0603
15
3
47N/50V/0603
GNDM
R39
+3.3V_SYS
FG
R332
150/F/0402
C31
U10-46
SPINDLE
C25 0.47U/16V/0603
150/F/0402
R238
C30
R36
0/J/0402
GNDM
(9)
0.47U/16V/0603
NC
R240
R37 5.1K/F/0402
48
DMO
1
1
R235
1.2K/F/0402
NC
R242
FOCUS
IN5
(9) DMO
GNDM
R244
R38 12K/F/0402
U10-45
C27 0.01U/50V/0603
SLO
1
R234
1.2K/F/0402
C26
TP41
D
TRACKING
INSP
(9) SLO
GNDM
CPH
TP40
0.01U/50V/0603
SPCNF
(9) FOO
4
1
R232
1K/F/0402
C28
TP39
C
14
TP38
(9) TRO
B
1
TRAY MOTOR
CONTROL
C420
R30
NC
TP36
1
1U/25V/0603
GNDM
R69
330/F/0402
GNDM
U2
IN5
+3.3V_SYS
VH
1
+5V_M
C211
0.1U/25V/0603
C421 TP37
(4) HU-
VCC
B0
3
GND
2
B1
1
S
SVREF (9)
GNDM
EJECT_SW (9)
NC7SB3157
1
TP35
1U/25V/0603
(4) HV+
1
A
5
6
(9) CLOSE
(4) HU+
2
TC14
47U/10V/B
4
1
1
(4) HV-
GNDM
(4) HW+
Title
(4) HW(4) VH
Size
MOTOR DRIVE
Document Number
Rev
F
WDR830 SYSTEM BOARD
Date:
A
B
C
D
Sheet
E
7
of
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
D
D
FB22
1A/600OHM/0603
3V3_EE
+3.3V_SYS
C185
0.1U/25V/0603
C
C
U20
24C04
1
2
3
4
A0
A1
A2
GND
R225
4.7K/F/0603
VCC
WP
SCL
SDA
8
7
6
5
R226
4.7K/F/0603
EE_SCL
EE_SDA
R224 0/J/0603
R227 0/J/0603
SCL (6,9,21)
SDA (6,9,21)
I2C ADDR = 0XA0
B
B
A
A
Title
EEPROM
Size
A
Document Number
Date:
5
4
3
Rev
F
WDR830 SYSTEM BOARD
2
Sheet
8
of
1
28
A
B
R72
0.2A/1KOHM/0402
R80
100K/F/0402
USB
USB_N0
USB_P0
DBANK0 (12)
DBANK1 (12)
DCS0 (12)
DRAS0 (12)
DCAS (12)
DB[0..15] (12)
DMA[0..11] (12)
DRAS0
DCAS
DCKE
DWE
+3.3V_D
LA16
LA15
LA14
LA13
LA12
2
LA[0..21] (10)
RF
C69 680P/50V/0402
C71 680P/50V/0402
R103
0/J/0402
+3.3V_RF
PVC
PVC
MIN
H
G
F
E
D
C
B
A
DRFP
DRFN
+3.3V_AVD
+3.3V_D
+1.45V
R268 33/J/0402
+1.45V
R83 0/J/0402 CDMDI
R91 0/J/0402
TRO
SLO
R93 0/J/0402 FOO
DMO
C239 0.1U/16V/0402
TP96
TP112
1
TP95
1
TP91
C82 1N/50V/0402
C81 100P/50V/0402
R119 0/J/0402 DVDMDI
DVDPD
PVC
CDLDO
DVDLDO
R118 10K/F/0402
C84 22N/25V/0603 MIN
PI
SVREF
FE
TE
C80
C79
C78
C77
C83
NC
NC
4.7N/50V/0402
1N/50V/0402
0.15U/25V/0603
GND_RF
+3.3V_RF
EJECT_SW
SW3
CLOSE
SW4
AMPSTBY
CD_DVDCT
AUX7
8380-129
1
1
1
1
R117 4.7K/J/0402
1
VDAC
FDAC
RSET
COMP
VREF
TP108
TP97
TP105
TP98
1
1
TP109
TP100
1
TP111
TP101
R109 1A/600OHM/0603
S_C
R108 1A/600OHM/0603
S_Y
R420 0/J/0603
GNDV
MOTOR
FG-LCS2
AMPSTBY
8380_CVBS
R107 1A/600OHM/0603
1
TP106
R106 910/F/0603
GNDV
C74 0.1U/25V/0603
+3.3V_V
C73 0.1U/25V/0603
GNDV
LOE
LA1
EAUX03
EAUX02
0/J/0402
33P/50V/0402
SLO
FOO
DMO
TRO
FG
(7)
AMPSTBY (7)
(7)
(7)
(7)
(7)
2
LCS1
LCS1 (10,19)
LD[0..7] (10,19)
R333 330/F/0603 SPDIFOUT
+3.3V_PLL
1
1
J18
R94
4.7K/J/0603
TP82
TP87
+3.3V_USB
EXT IO
R469
NC
EAUX03
USB_P0
USB_N0
ADC_BIAS
4.7K/J/0402
C62
330P/50V/0603
SPACE=35MIL
VERY CLOSE 8380
R329
68K/J/0603
SPACE=7 MIL
+3.3V_D
SPACE=35 MIL
1.0/VA/WAFER
4
GND
3
TX
2
RX
1
+5V
GND GUARD
WIDTH=7mil, 1 VIA
GND_POWER
TXD
RXD
+5V_SYS
WIDTH=7mil, 1 VIA
GND GUARD
IR
1
C47
0.1U/16V/0402
+3.3V_D
TC25
47U/10V/B
C254
0.1U/16V/0402
1
IR_IN (21,24)
AUX7
R116 33/J/0402
AVOUT_DET (3)
2
C45
0.1U/16V/0402
C231
0.1U/16V/0402
C238
0.1U/16V/0402
C216
0.1U/16V/0402
C215
0.1U/16V/0402
+3.3V_DAC
+3.3V_V
+3.3V_RF
REFD
PVC
1
+3.3V_PLL
TC20
47U/6.3V/A
TC21
100U/6.3V/B
C240
0.1U/25V/0603
Title
ES8380
Size
Document Number
2
2
C248
0.1U/16V/0402
C244
0.1U/16V/0402
C
C249
0.1U/16V/0402
C247
0.1U/16V/0402
C243
0.1U/16V/0402
C252
0.1U/16V/0402
C237
0.1U/16V/0402
C251
0.1U/16V/0402
C235
0.1U/16V/0402
C227
0.1U/16V/0402
C218
0.1U/16V/0402
B
C236
0.1U/16V/0402
1
+3.3V_AVD +3.3V_USB
C52
0.1U/16V/0402
AVINDET-AUX5 (3)
SPDIFOUT (14)
A
SLO
FOO
DMO
TRO
GND_POWER
+1.45V
C234
0.1U/16V/0402
SILENCE_DET (13)
AVINDET-AUX5
SPDIFOUT
R73
C422
R270
4.7K/J/0603
AU_MCK (14)
ANALOG
SILENCE_DET
C214
0.1U/16V/0402
FB72 FBMA-11-100505-102T
AU_LRCK (14)
C213
0.1U/16V/0402
R115 1K/F/0603
C413
NC
C217
0.1U/16V/0402
8380-129
AU_D0 (14)
AU_BCK (14)
C233
0.1U/16V/0402
8380-117
FB71 FBMA-11-100505-102T
C250
0.1U/16V/0402
I2S
R111 1K/F/0603
R114 1K/F/0603
C412
NC
R110 1K/F/0603
TDR086L
C70
47N/25V/0603
C232
0.1U/16V/0402
8380-118
8380-124
CD_DVDCT (4)
+3.3V_V
SVREF
1
PVC (4)
DVDMDI (4)
CDMDI (4)
SVREF (7)
RF
(4)
A
(4)
B
(4)
C
(4)
D
(4)
E
(4)
F
(4)
TP110
1
1
3
CDLDO (4)
DVDLDO (4)
+3.3V_D
close ES8380
AUDIO
R121 3.3K/F/0402
CD_DVDCT
+3.3V_DAC
SW1 (4)
SW2 (4)
SW3 (4)
SW4 (4)
EJECT_SW (7)
OUT_SW (4)
CLOSE (7)
R120 6.8K/F/0402
PVC
DVDMDI
CDMDI
SVREF
RF
A
B
C
D
E
F
+3.3V_D
TP99
SW1
SPNP
SW3
SW4
EJECT_SW
SPNP
CLOSE
CDLDO
DVDLDO
+3.3V_D
+1.45V
RXD
TXD
8380-124
8380-123
1
TP176
8380-122
1
TP177
R432 0/J/0603
8380-119
8380-118
8380-117
IDAC
UDAC
CDAC
YDAC
+3.3V_D
TE
LD[0..7]
R98
LD1
LD0
+3.3V_D
+3.3V_D
33/J/0402
33/J/0402
S_Y (21)
S_C (21)
8380_CVBS (26)
R92
R85
SILENCE_DET
VIDEO
S_Y
S_C
8380_CVBS
33/J/0402
33/J/0402
33/J/0402
33/J/0402
33/J/0402
33/J/0402
EEPROM
R82
R79
R81
R78
R77
R76
I2C_INT (21)
SCL (6,8,21)
SDA (6,8,21)
R421 0/J/0402
I2C_INT
SCL
SDA
SPNP
SPNN
+3.3V_D
R102 33/J/0402
R99 33/J/0402
Flash ROM
LCS3
LA11
LA10
LA9
LA20
LOE (10)
WRLL (10)
8380RST (10,11)
FG-LCS2 (10)
LCS3 (10)
LD7
LD6
LD5
LD4
LD3
LD2
LOE
WRLL
8380RST
FG-LCS2
LCS3
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
LD[0..7] (10,19)
+1.45V
LD[0..7]
LA2
LA17
LA0
LCS0
LCS1
FG-LCS2
LA[0..21]
V2.2
+3.3V_D
4.7K/J/0402
+3.3V_D
DB8
DB9
DB10
DB11
DB12
DB13
DB14
DB15
FE
FE
TE
SPNP / MNTRP / IMSR
SPNN / MNTRN
AGC1
AGC2
DVDPD
VB0
CDLD
DVDLD
REX
PI
V165O
FE
TE
MB
DB
MP
VGB
VPB
OPEN / VOBS
OPENSW
CLOSE
CLOSESW
AMPSTBY
LDCO
AUX7 / RXD1/SOUT
VS33
VD33
MCLK
VSS
VDD
RXD0 / AUX14 / STEP_RDR / LINE_OR / SIN
TXD0 / AUX15 / STEP_FDR / LINE_OL / SOUT
TBCK / PWM_O1R / EAUX01
TSD3 / PWM_O3R / EAUX00
TSD2 / PWM_O3L
VS33
VD33
TSD1 / PWM_O2R
TSD0 / PWM_O2L
TWS / PWM_O1L/TXD1
IDAC
UDAC
CDAC
YDAC
VS33DAC
VD33DAC
VDAC
FDAC
RSET
COMP
VREF
VS33PLL
ES8380
LA7
LA6
LA5
LA4
LA3
4.7K/J/0402
R62
R61
4.7K/J/0402
+3.3V_D
DSCK
DQM
DB7
DB6
DB5
DB4
DB3
DB2
DB1
DB0
VD33
DMA7
DMA8
DMA9
DMA3
DMA2
DMA1
DMA0
VS33
VD33
DMA10
DMA11
DRAS2#
DRAS1#/DCS1_B
DCS1#/VSYNC/CAM_CLK/TDMDR/RSD/HOMESW
DCS0#
VDD
VSS
SEL_PLL2 / DRAS0#
SEL_PLL3 / DCAS#
SEL_PLL0 / DOE#
SEL_PLL1 / DWE#
VS33
VD33
DSCK
DQM
DB7
DB6
DB5
DB4
DB3
DB2
DB1
DB0
VS33
VD33
DB8
DB9
DB10
DB11
DB12
DB13
DB14
DB15
VS33
VD33
LA16
LA15
LA14
LA13
LA12
VS33
+1.45V
4.7K/J/0402
DCKE
DWE
DRAS0
DCAS
R59
PLL0
PLL1
PLL2
PLL3
R60
+3.3V_D
CAMCLK (6)
R128
4.7K/J/0402
+1.45V
FLAG[0..7] (6)
4
33/J/0402
R130
4.7K/J/0402
3
R63
DSS1
R127
4.7K/J/0402
DBANK1
DBANK0
DSS1
DCS0
33/J/0603
33/J/0603
33/J/0603
33/J/0603
33/J/0603
33/J/0603
33/J/0603
33/J/0603
R129
4.7K/J/0402
1
2
3
4
FLAG0
FLAG1
FLAG2
FLAG3
FLAG4
FLAG5
FLAG6
FLAG7
R246
R251
R254
R259
R264
R266
R269
R271
R280
4.7K/J/0402
DMA1
DMA0
DMA10
DMA11
R_FLAG0
R_FLAG1
R_FLAG2
R_FLAG3
R_FLAG4
R_FLAG5
R_FLAG6
R_FLAG7
R248
4.7K/J/0402
1
2
3
4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
LA21
WRLL
LA19
LA18
LA8
SDRAM
DMA8
DMA9
DMA3
DMA2
RP6
+3.3V_D
33/J/8P4R/2010
8
7
6
5
RP7 33/J/8P4R/2010
8
7
6
+3.3V_D
5
Close IC
SCL
SDA
VD33
LA11
LA10
LA9
LA20
VS33
VD33
LA21
LWRLL#
LA19
LA18
LA8
VSS
VDD
LA7
LA6
LA5
LA4
LA3
VS33
VD33
LA2
LA17
LA0
LCS0# / GPIO MUTE
LCS1#
LCS2# / HSYNC / FGIN / TDMFS / RWS
VDD
VSS
LCS3#
LD7
LD6
LD5
LD4
LD3
LD2
VS33
VD33
LD1
LD0
LOE#
LA1
PAD_CNTL / SPDIF_OUT / EAUX03
SPDIF_IN / EAUX02
AVD33
USB_P0
USB_N0
ADC_BIAS
MIC_L
MIC_R
AVS33
VD33PLL
DMA[0..11]
+3.3V_D
DB[0..15]
U8
+3.3V_D
RP5
33/J/8P4R/2010
8
7
6
5
Tuner Interface
FLAG[0..7]
VS33
DMA6
DMA5
DMA4
AUX1
RESET#
AUX3/IP2
AUX0
AUX2/IP1
AUX6 / IDSEL/SIN
AUX4
AUX5 / LG
VDD
VSS
FLAG0/GPI/TP/AUX30/CAMIN0/SD
FLAG1/GPIO/TP/AUX31/CAMIN1/THM_W
FLAG2/GPIO/TP/AUX32/CAMIN2/P_DWN_DRV
FLAG3 / GPIO / TP / AUX33 / CAMIN3
VD33
VS33
CLK / TDMCLK / RBCK
VID_XO
VID_XI
FLAG6 / AUX36 / CAMIN6
FLAG7 / AUX37 / CAMIN7
VS33
VD33
DVCC
AVS33
AVD33
REFD
CDPD
TRO
SLO
FOO
DMO
SLV
MIN
H
G
F
E
D
C
B
A
DRFP
DRFN
VGA
VPA
DCS0
DRAS0
DCAS
1
2
3
4
REFD
CDPD
DMA4
DMA5
DMA6
DMA7
GND_RF
USB_N0 (5)
USB_P0 (5)
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
DWE (12)
DSCK (12)
DQM (12)
CPUCLK
XOUT
XIN
R_FLAG6
R_FLAG7
Close IC
GND_RF
R_FLAG0
R_FLAG1
R_FLAG2
R_FLAG3
R_FLAG4
R_FLAG5
TP166
R245 0.2A/500OHM/0402 SCL
8380RST
R247 0.2A/500OHM/0402 SW1
R249 0.2A/500OHM/0402 SDA
R253 0.2A/500OHM/0402 AUX2
I2C_INT
R255 0.2A/500OHM/0402
IR_IN
R260 0.2A/500OHM/0402
R263 0.2A/500OHM/0402 AVINDET-AUX5
R265 100K/J/0603
R261
NC
R256 4.7K/J/0402
R252 100K/J/0603
C59
22P/50V/0603
4
DBANK0
DBANK1
E
XIN
+3.3V_D
DWE
DSCK
DQM
D
XOUT
R75
0/J/0402
XT1
27M/HC-49SMA
C51
22P/50V/0603
C
Rev
F
WDR830 SYSTEM BOARD
GND_RF
Date:
D
E
Sheet
9
of
28
5
4
3
2
1
+3.3V_FLASH
U22
LA16
LA15
LA14
LA13
LA12
LA11
LA10
LA9
LA20
LA21
WRLL
8380RST
D
LA19
LA18
LA8
LA7
LA6
LA5
LA4
LA3
LA2
C
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
A15
A14
A13
A12
A11
A10
A9
A8
NC
NC
W
RP
VPP
DU/WP
NC
NC
A17
A7
A6
A5
A4
A3
A2
A1
A16
BYTE
GND
DQ15/A_1
DQ7
DQ14
DQ6
DQ13
DQ5
DQ12
DQ4
VCC
DQ11
DQ3
DQ10
DQ2
DQ9
DQ1
DQ8
DQ0
OE
GND
CE
A0
MX29LV160CTTC-70G
+3.3V_FLASH
+3.3V_FLASH
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
LA17
LA0
LD7
D
LD6
Z1
LD5
LD4
LD3
LD2
R334
NC
LD1
+3.3V_SYS
LD0
LOE
R267
NC
+5V_SYS
FLASH_CS
LA1
R88
4.7K/J/0603
R90
0/J/0603
LCS3
R89
NC
FG-LCS2
R470
NC
LCS1
R405
0/J/0603
R335
NC
C66
0.1U/25V/0603
36
35
34
33
32
31
30
29
28
27
26
25
LA19
LA18
LA8
LA7
LA6
LA5
LA4
LA3
LA2
GND_POWER
+3.3V_SYS
B
C48
0.1U/25V/0603
LA16
LA15
LA14
LA13
LA12
LA11
LA10
LA9
LA20
LA21
WRLL
8380RST
LA17
ROMSEL
LA0
LD7
LD6
LD5
LD4
LD3
LD2
LD1
LD0
LOE
LA1
C49
0.1U/25V/0603
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
C
B
36P/0.5/DOWN/FPC
GND_POWER
LA[0..21]
LD[0..7]
A
LOE
WRLL
8380RST
FG-LCS2
LCS3
LCS1
LA[0..21] (9)
LD[0..7] (9,19)
LOE (9)
WRLL (9)
8380RST (9,11)
FG-LCS2 (9)
LCS3 (9)
LCS1 (9,19)
A
Title
Size
A4
Date:
5
4
3
2
FLASH ROM
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
10
1
of
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
D
D
+3.3V_SYS
+5V_SYS
R336
4.7K/J/0603
R337
10K/J/0603
C
2
GND
RST
VCC
4
MR
3
FB73
0/J/0603
(9,10) 8380RST
D
C323
0.1U/25V/0603
R338
1K/J/0603 G
Q45
2N7002
C324
NC
S
1
C
MRST (21)
U23
G692L263TCUF
VC5
NC
(24) BOTMRST
B
B
A
A
Title
RESET
Size
A
Document Number
Date:
5
4
3
Rev
F
WDR830 SYSTEM BOARD
2
Sheet
11
of
1
28
5
D
DMA10
DMA0
DMA1
DMA2
MMA10
MMA0
MMA1
MMA2
DMA4
DMA5
DMA6
DMA7
MMA4
MMA5
MMA6
MMA7
DMA8
DMA9
DMA11
MMA8
MMA9
MMA11
R231
49.9/F/0603
4
R_DSCK
C193
NC
R474
NC
C414
6.8P/50V/0402
DMA3
23
24
25
26
29
30
31
32
33
34
22
35
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
R_DSCK
38
CLK
CKE
37
CKE
CS0
+3.3V_SD
19
CS
RAS0
18
RAS
CAS
17
CAS
WE
16
WE
DQMX
15
39
DQML
DQMH
20
21
BA0
BA1
36
40
NC
NC
CKE
BANK0
BANK1
DQM
DWE
DCAS
DRAS0
DQMX
WE
CAS
RAS0
DBANK0
BANK0
DBANK1
BANK1
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
CS0
C
R230
4.7K/J/0603
1
RP3
MMA0
MMA1
MMA2
MMA3
MMA4
MMA5
MMA6
MMA7
MMA8
MMA9
MMA10
MMA11
MMA3
DCS0
2
U3
R487
0/J/0805
DSCK
3
2
4
5
7
8
10
11
13
42
44
45
47
48
50
51
53
VCC
VCC
VCC
1
14
27
VCCQ
VCCQ
VCCQ
VCCQ
3
9
43
49
VSSQ
VSSQ
VSSQ
VSSQ
6
12
46
52
VSS
VSS
VSS
28
41
54
MB0
MB1
MB2
MB3
MB4
MB5
MB6
MB7
MB8
MB9
MB10
MB11
MB12
MB13
MB14
MB15
+3.3V_SD
DB0
DB1
DB2
DB3
1
2
3
4
8
7
6
5
MB0
MB1
MB2
MB3
33/J/8P4R/2010
D
RP4
DB4
DB5
DB6
DB7
1
2
3
4
8
7
6
5
MB4
MB5
MB6
MB7
33/J/8P4R/2010
RP2
DB11
DB10
DB9
DB8
1
2
3
4
8
7
6
5
MB11
MB10
MB9
MB8
33/J/8P4R/2010
RP1
DB15
DB14
DB13
DB12
1
2
3
4
8
7
6
5
MB15
MB14
MB13
MB12
C
33/J/8P4R/2010
M12L64164A-6TG
B
B
+3.3V_SD
DWE
DSCK
DQM
DBANK0
DBANK1
DCS0
DRAS0
DCAS
A
DB[0..15]
DMA[0..11]
DWE (9)
DSCK (9)
DQM (9)
C192
0.1U/16V/0402
C191
0.1U/16V/0402
C199
0.1U/16V/0402
C203
0.1U/16V/0402
C202
0.1U/16V/0402
C200
0.1U/16V/0402
DBANK0 (9)
DBANK1 (9)
DCS0 (9)
DRAS0 (9)
DCAS (9)
A
DB[0..15] (9)
Title
DMA[0..11] (9)
Size
A4
Date:
5
C201
0.1U/16V/0402
4
3
2
SDRAM
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
12
1
of
28
4
3
2
1
1
5
2
EC1
220U/6.3V/SMD63*58
6011HP_ROUT
+5V_AUD
TC17
100U/6.3V/B
C229
0.1U/25V/0603
D
Q9
2SD1328
C228
0.1U/25V/0603
2
TC18
100U/6.3V/B
2
C230
0.1U/25V/0603
A
R34
1K/J/0603
2
1 B
E
SPK_R+
1
1
D
HP_R_OUT (3)
D6
MA2J728
K
C
H:MUTE
L:ACTIVE
HP_MUTE
R35
10K/F/0603
+5V_AUD
R449 0/J/0603
R450 0/J/0603
(14) DAC-LIN
(3) AVIN_LIN
C326 1U/16V/0603
C56 1U/16V/0603
C57 1U/16V/0603
+5V_AUD
HP1_DET (3)
A
R56
Headphone and speaker difference
Headphone max volume
(500ms Fade On)
C39 1U/16V/0603
HP2_DET (3)
AVIN_SW
0/J/0603
R57 100K/F/0603
R58 100K/F/0603
R419 NC
C
LM312-004-TF1-3
J5
4P/2.0/RA/WAFER
SPK_R+
SPKR+ 1
SPKR- 2
SPK_RSPKL+ 3
SPK_L+
SPKL- 4
SPK_L-
AVIN_SW (19)
VOLUME (21)
+5V_AUD
TP169
TP170
TP171
TP172
SYS_MUTE
L:MUTE
H:ACTIVE
R29
Q46
4.7K/J/0603 PMBS3906
E
C
+5V_SYS
HP_MUTE
B
B
SPK_L+
25
+5V_AUD
100K/F/0603J
G2
C54 1U/16V/0603
C55 1U/16V/0603
C325 1U/16V/0603
24
23
22
21
20
19
18
17
16
15
14
13
G1
(3) AVIN_RIN
(14) DAC-RIN
+5V_AUD
ROUT+
PGND1
SE/BTL
ROUTPVDD1
HP/ LINE
RHPIN
VOLUME
RLINEIN
SEDIFF
RIN
SEMAX
VDD
AGND
BYPASS
LIN
LLINEIN
FADE
LHPIN SHOTDOWN
PVDD2
LOUT+
LOUTPGND2
GND
1
2
3
RHPIN
4
RLINEIN 5
6
7
8
LLINEIN
9
LHPIN
10
11
SPK_L- 12
SPK_R-
R87
100K/F/0603
R55
C
D8
BAV70-F
K
R86
100K/F/0603
R418
2.2M/F/0402
R417
2.2M/F/0402
U7
TPA6011A4PWPR
B
Default Output
R27
1
1K/J/0603
SYS_MUTE
K
C
R5
10K/J/0603
B
D5
RLS4148N
Q4
PMBS3904
L:MUTE
H:ACTIVE
K IO_MUTE
F/W control
A
HP_MUTE
A
H:MUTE
L:ACTIVE
IO_MUTE (19)
HP_L_OUT (3)
D7
MA2J728
K
R51
1K/J/0603
2
1 B
D25
NC
K
C
Q53
PMBS3904
E
+
R422
4.7K/J/0603
A
B
A
B
SILENCE_DET (9)
Title
Q54
PMBS3904
Size
B
E
R451
100K/J/0603
R423
GND_POWER
1K/J/0603
C
+5V_SYS
GND_POWER
5
Q10
2SD1328
R49
10K/F/0603
C5
NC
A
(19) AVIN_SW
2
D2
RLS4148N
A
+
E
R23
1M/F/0603
Reset
EC2
220U/6.3V/SMD63*58
6011HP_LOUT
E
1
TC1
100U/6.3V/B
R24
100/J/0603
+
2
SYS_MUTE (14)
TP6
C
+5V_SYS
4
Date:
3
2
AUDIO STEREO AMPLIFER
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
1
13
of
28
5
4
3
2
1
R160
56K/F/0402
DAC-LIN (13)
FB58
1A/600OHM/0603
OPVCC-
R169
30K/F/0402
4
TC10
47U/10V/B
R291
1K/F/0603
2
OPREF
3
+
TC9
47U/10V/B GND_SIGNAL
C118
820P/50V/0402
C388
NC
2
2
U10A
UTC 3308L
R138
47K/J/0402
8
C278
2.2N/50V/0603
C407
10U/16V/1206
1
+
D
-
4334-LOUT
-5V_SYS
C406
0.1U/25V/0603
1
R144
220/F/0402
1
2
R142
1K/F/0402
2
1 B
Q17
2SD1328
D
AVOUT_L (3)
1
C92
1N/50V/0402
E
H:MUTE
L:ACTIVE
R143
220/J/0402
1
2
C
C109
56P/50V/0402
FB17
1A/600OHM/0603
GND_SIGNAL
OPVCC+
+5V_SYS
C270
0.1U/25V/0603
1
R286
0/J/0402
TC33
47U/10V/B
2
C269
NC
+5V_SYS
GND_SIGNAL
GND_SIGNAL
R124
4.7K/J/0603
SYS_MUTE
L:MUTE
H:ACTIVE
Q47
B
C
PMBS3906
C
(13) SYS_MUTE
MA2J728
K
MA2J728
K
E
R122
1K/J/0603
C
D10
A
D9
A
R482
10K/J/0603
C419
10U/10V/1206
R140
56K/F/0402
DAC-RIN (13)
C94
56P/50V/0402
OPVCC-
+
5
C89
820P/50V/0402
1
U10B
UTC 3308L
2
+5V_D
R134
47K/J/0402
OPVCC+
B
R125
220/F/0402
2
R131
1K/F/0402
1
2
1
8
C390
NC
+
OPREF
C259
2.2N/50V/0603
TC7
47U/10V/B
7
1
C
4
6
Q15
2SD1328
B
H:MUTE
L:ACTIVE
R132
220/J/0402
2
AVOUT_R (3)
2
1
C88
1N/50V/0402
E
4334-ROUT
R133
30K/F/0402
-
TC6
47U/10V/B
R284
1K/F/0603
B
GND_SIGNAL
R339
0/J/0402
R340
0/J/0402
Q48
NC
B
E
(9) SPDIFOUT
C
R454
NC
R455
0/J/0402
R341
NC
R342
0/J/0402
COAX
COAX (3)
R343
NC
C329
NC
R456
R457
R458
R459
AU_D0
AU_BCK
AU_LRCK
AU_MCK
33/F/0603
33/F/0603
33/F/0603
33/F/0603
U9
CS4334-KSZ
1
2
3
4
SDATA AOUTL
DEM/SCLK VA
LRCK
AGND
MCLK AOUTR
8
7
6
5
FB57
1A/600OHM/0603
4334-LOUT
A
+5V_SYS
4334-ROUT
C263
0.1U/25V/0603
TC34
47U/10V/B
2
(9)
(9)
(9)
(9)
1
A
GND_SIGNAL
Title
AUDIO FILTER
Size
A3
Document Number
Date:
5
4
3
2
Rev
F
WDR830 SYSTEM BOARD
Sheet
1
14
of
28
5
4
3
2
VIN_ADA_BAT
OVP
Q22
RSQ030P03
1
4
2
5
6
G1
DC-JACK-IN
82K/J/0603
K
R467
External-BAT (21)
R157
NC
4.7K/J/0603
C
C
Q19
PMBS3904
Q55
PMBS3904
B
C144
10U/16V/1206
E
E
Q56
PMBS3904
B
R463
NC 100K/J/0603
R465
15K/J/0603
R148
1K/F/0603
R464
1K/F/0603
MH2
MH
C
GND_DC
VCC_CHG
1
INTBAT+
GND_DC
TS
1
(18)
R302
27K/F/0603
VIN_ADA_BAT
Q40
RSQ030P03
1
4
2
5
6
TP141
D16
NC
A
K
Q57
R307
100K/F/0603
1
2
5
6
3
G2
G1
LM311C-003-TX3
J15
3P/2.0/VA/WAFER
BAT + 1
BAT - 2
Temp Sensor 3
TP138
4
EXTCHG_VCC
Q43
R330
TP178
VIN_SYS
1
G1
NC 10K/F/0603
GND_DC
NC PMBS3904
TP179
B
1K/F/0603
E
8.2K/J/0603
INTBAT_DISCHG (21)
PMBS3904
E
1K/F/0603
Q39
PMBS3904
E
R315
B
B
B
C
B
R331
LM103-004-TX3
J17
1
4P/1.25/RA/WAFER
4
3
2
1
3
R305
C
C
Q44
EXTCHG_VCC
DVBT POWER
RSQ030P03
G2
6
9
B
D
R466
Charging-EN (18)
A
E
3
2
1
8
7
GND_DC
C393
10P/50V/0603
C392
10P/50V/0603
IOSLATOR
VIN_SYS
R462
82K/J/0603
D28
UDZ6.8B
A
G2
GND_DC
1
C
R461
1.5K/F/0603
R473
NC
Q20
PMBS3904
B
F2
467004.NR
+5V_SYS
C
D11
UDZ13B
P6
4
5
R168
100K/F/0603
3
R147
1K/F/0603
FB64
2A/600OHM/0805
3
R150
100K/F/0603
K
FB63
2A/600OHM/0805
2
C283
0.1U/50V/0603
C382
0.1U/50V/0603
J11
DCJ-01-BLACK
1
D12
RB051L-40
K
A
C
FB59
2A/600OHM/0805
FB62
2A/600OHM/0805
D
1
EXTCHG_VCC
E
INPUT
DC 9V 2.0A
VC1
or 1.8A
10P/50V/0603
R221
0/J/0603
+5V_SYS
GND_DC
R314
1K/F/0603
C178
0.1U/25V/0603
GND_DC
GND_DC
R203
(21) BATLIFE_DET
+5V_SYS
R479
0/J/0402
R215
0/J/0603
C173
0.1U/25V/0603
U17
4
A
5
VCC
6
S
NC7SB3157
B0 3
GND
2
B1
1
EXTBAT+OUT
VCC3_3
GND_DC
INTBAT+
R199
100K/J/0603
U16
APC558KC
INTBAT+OUT
1 AOUT
VDD
8
AIN-
BOUT
7
AIN+
BIN-
6
R220
100K/J/0603
R198
100K/F/0603
2
3
EXTBAT+OUT
100K/F/0603
INTBAT+OUT
R202
100K/F/0603
4
GND
BIN+
R219
100K/F/0603
VCC3_3
R218
100K/F/0603
5
EXTCHG_VCC
GND_DC
(21) BATDET_SEL
GND_DC
GND_DC
R217
100K/F/0603
A
A
Title
Adapter IN
Size
Document Number
Custom
Rev
F
WDR830 SYSTEM BOARD
Date:
5
4
3
2
Sheet
1
15
of
28
5
4
3
2
1
+5V_SYS
C165
10U/6.3V/1206
C160
100P/50V/0603
R190
300K/F/0603
D
+3.3V_tuner
D
+3.3V_SYS
R304
100K/F/0603
L7
2.2UH/1A
U14
R184
0/J/0603
GND_DC
L6
2.2UH/1A
EN1
SW1
10
2
FB1
GND1
9
3
IN2
IN1
8
4
GND2
FB2
7
5
SW2
EN2
6
EPAD
C294
1U/16V/0603
1
C161
10U/6.3V/1206
C290
10U/6.3V/1206
C395
0.1U/50V/0603
R311
100K/F/0603
C297
NC
R206
300K/F/0603
C303
10U/6.3V/1206
C394
10U/6.3V/1206
MP2109DQ
+1.45V
C
C133
10U/6.3V/1206
R208
200K/F/0603
11
R185
68K/F/0603
FB65
1A/600OHM/0603
C
C166
0.1U/50V/0603
GND_DC
+3.3V_SYS
FB28
1A/600OHM/0603
+3.3V_RF
1
+3.3V_SYS
+3.3V_V
TC22
47U/6.3V/A
C245
0.1U/50V/0603
C417
100P/50V/0603
TC26
47U/6.3V/A
C255
0.1U/50V/0603
B
GND_RF
2
B
1
2
FB31
1A/600OHM/0603
+3.3V_FLASH
GND_DC
FB16
1A/600OHM/0603
FB25
1A/600OHM/0603
+3.3V_PLL
C253
0.1U/50V/0603
2
1
TC37
47U/6.3V/A
C375
0.1U/50V/0603
GND_POWER
FB41
1A/600OHM/0603
2
FB40
1A/600OHM/0603
C223
0.1U/50V/0603
GND_POWER
+3.3V_DAC
FB52
1A/600OHM/0603
GND_POWER
GND_POWER
+3.3V_AVD
TC35
47U/6.3V/A
2
TC24
47U/6.3V/A
TC3
47U/6.3V/A
2
1
TC36
47U/6.3V/A
C67
0.1U/50V/0603
2
C205
0.1U/50V/0603
1
FB30
1A/600OHM/0603
1
FB24
1A/600OHM/0603
1
GNDV
+3.3V_SD
+3.3V_D
+3.3V_USB
A
TC29
47U/6.3V/A
TC28
47U/6.3V/A
GND_POWER
C321
0.1U/50V/0603
Title
2
2
C322
0.1U/50V/0603
1
1
A
Size
B
GND_POWER
GND_POWER
5
4
Date:
3
2
+3.3V & +1.45V
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
1
16
of
28
5
4
3
D27
BAT54SW
A
C396
1U/16V/0603
2
R460
0/J/0603
-5V_SYS
C397
10U/10V/0805
J
D
C398
10U/10V/0805
K
1
C399
10U/10V/0805
D
GND_DC
SYS-ON-OFF (20)
H:Active
L:OFF
VC4
NC
+5V_Spe
+5V_SYS
1
C
C415
10U/35V/1206
IN
3
SW
9
gnd
6
FB
5
GND
4
R191
7.5K/F/0603
MP2307
C416
0.1U/50V/0603
A
D14
B240A-13-F
2
COMP
C146
NC
C174
C175
C176
NC
C400
10U/10V/1206
C401
0.1U/50V/0603
10U/10V/1210 10U/10V/1210
C
R204
10K/F/0603
C145
10U/35V/1206
K
VIN_SYS
BS
C140
3.3N/50V/0603
GND_DC
EN 7
R201
43K/F/0603
D29
RLS4148N
U15
8 SS
C156
1N/50V/0603
L9
C298
22UH/2.6A 10N/50V/0603
K
A
+
FB66
2A/600OHM/0805
GND_DC
GND_DC
B
+5V_Spe
R488
0/J/1206_R
GND_DC
+5V_SYS
FB19
1A/600OHM/0603
+5V_D
+5V_AUD
B
1
TC27
47U/10V/B
NR6012T/22UH/760mA
TC19
47U/10V/B
C86
0.1U/50V/0603
2
C224
0.1U/50V/0603
2
1
L15
GND_POWER
GND_DC
+5V_M
FB32
1A/600OHM/0603
+5V_RF
1
FB26
1A/600OHM/0603
TC39
47U/10V/B
1
TC16
47U/10V/B
2
C221
0.1U/50V/0603
C262
0.1U/50V/0603
A
2
A
Title
GNDM
Size
A4
GND_RF
Date:
5
4
3
2
+5V
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
17
1
of
28
5
4
3
2
1
1
TP118
D
D
3 2 1
VCC_CHG
L5
10UH/1.14A
EXTCHG_VCC
10
21
C108
0.1U/25V/0603
S
20
R172
8.66K/F/0603
BAT_CURRENT
CELL_SEL
Charging-EN (15)
R178 100K/F/0603
EXTCHG_VCC
U12
BQ24103RHLR
VTSB
TS
TS
(15)
R177
22K/F/0603
B
C128
0.1U/25V/0603
C
G
D
Q21
2N7002
Q23
PMBS3904
E
B
STAT2
PGND
PGND
CE
SNS
BAT
CELLS
TS
19
18
17
16
15
14
13
12
R412
0/J/0603
R182
10K/F/0603
R176
7.5K/F/0603
R181
100K/F/0603
R170
22K/F/0603
R175
15K/F/0603
EXTCHG_VCC
+5V_SYS
STAT1
IN
IN
PG
VCC
TTC
ISET1
ISET2
C97
0.1U/25V/0603
OUT
2
3
4
5
6
TIME_TER_CTRL 7
FAST_CHG
8
PRE-CHG9
C404
0.22U/25V/0603
VTSB
CHARGE
C
VTSB
11
1
GND_DC
OUT
1
C107
10U/35V/1210
C106
10U/35V/1210
TP116
C
C96
10U/16V/1206
VSS
21
(24) BATFAIL_DET
B
R159
0.1/F/1206
L:FULL CHARGE
H:HALF CHARGE
A
A
Title
Size
A4
Date:
5
4
3
2
Charger
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
18
1
of
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
+3.3V_SYS
LCS1
3
4
7
8
13
14
17
18
R41 33/J/0603 11
D0
D1
D2
D3
D4
D5
D6
D7
CLK
U4
74HC374DWR
Q0 2
Q1 5
Q2 6
PWR-TUNER
Q3 9
AVIN-SW
Q4 12 MU-TE
Q5 15
Q6 16 DVB-RST
Q7 19
OC
D
1
1
1
TP50
TP49
TP165
1
TP42
1
10
(9,10) LCS1
LD0
LD1
LD2
LD3
LD4
LD5
LD6
LD7
20
LD[0..7]
(9,10) LD[0..7]
10
D
20
C29
0.1U/25V/0603
C37
10P/50V/0603
C
C
+5V_SYS
+5V_SYS
R21
4.7K/J/0603
R28
NC
PWR_TUNER
R68
NC
IO_MUTE (13)
PWR-TUNER
C
IO_MUTE
H:MUTE
L:ACTIVE
C
R32
1K/J/0603
MU-TE
R70
NC
R363
0/J/0603
Q11
NC
B
Q7
PMBS3904
E
B
PWR_TUNER (6)
L:Active
H:OFF
B
E
B
+5V_SYS
+5V_SYS
R22
4.7K/J/0603
R20
4.7K/J/0603
C
Q6
PMBS3904
L:RESET
H:NORMAL
AVIN-SW
R33
1K/J/0603
B
AVIN_SW (13)
H:Active
L:OFF
Q8
PMBS3904
E
DVB-RST
R31
1K/J/0603
B
DVB_RST (6)
C
AVIN_SW
DVB_RST
A
E
A
Title
EXT I/O
Size
A
Document Number
Date:
5
4
3
Rev
F
WDR830 SYSTEM BOARD
2
Sheet
19
of
1
28
5
4
3
2
1
D
D
2
VIN_SYS
H:ENABLE
L:DISABLE
1
R26
10K/J/0805
POWER_SWITCH (24)
VCC5
4
3
2
SW1
2
1
R19
10K/J/0603
C
1
C
POWER-KEY (24)
Q3
PMBS3904
B
R2
10K/J/0603
1
2
POWER-KEY
+
C
(21) ON_STOP_OFF
A
D1
RLS4148N
K
SYS-ON-OFF
SYS-ON-OFF (17)
K
C330
1
E
+
A
D4
RLS4148N
R25
47K/J/0603
2
0.1U/16V/0402
R346
B
VCC5
1
2
B
4.7K/F/0603
(21) POWER_ON_KEEPER
A
A
Title
Size
A4
Date:
5
4
3
2
POWER ON/OFF SWITCH
Document Number
Rev
F
WDR830 SYSTEM BOARD
Sheet
20
1
of
28
5
3
2
C113
75/F/0402_R
62/F/0402
15 mil
470P/50V/0603
C117 0.1U/25V/0603
C1NM
12MHz XTAL
XTAL_OUT
R167 0/J/0402
15 mil
GND_A
R296
R294
R295
VBOUT
VGOUT
VROUT
VCOMOUT
VCOMDC
10/F/0603
10/F/0603
10/F/0603
C101 20P/50V/0402
D
R173
13/F/0402
S_Y
R171 62/F/0402 C121 0.1U/25V/0603
Y1NP
R152 X1
12MHZ
AVDD_OPLL
C124
75/F/0402_R
62/F/0402
15 mil
1M/F/0603
15 mil
R180 0/J/0402
GND_A
15 mil
C134
62/F/0402
0.1U/16V/0402
C180
8
7
6
5
0.1U/16V/0402
VDDP
GND_A
470P/50V/0603
C137 0.1U/25V/0603
CVBS1M
C274 0.1U/16V/0402
GND_A
R153
C104
4.7K/J/0402
R154
15 mil
0.1U/16V/0402
4.7K/J/0402_R
GND_A
C280
C281
C279
1U/16V/0603
1U/16V/06030.1U/16V/0402
C277
GND_A
C1NP
C1NM
Y1NP
Y1NM
CVBS1P
CVBS1M
VCC5
R193
AVDD_GMC
100K/F/0603
AVDD_CCFL
0/J/0603
TP135
1
TP140
TP146
1
1
C143 0.1U/16V/0402
C150 0.1U/16V/0402
1
1
TP149
TP150
B
VDDC1
C162
10U/10V/1206
C157
C153
0.1U/16V/0402
0.1U/16V/0402
0.1U/16V/0402
C289
AVDD_PWM
U13
MST720A
PWM POWER AND CHARGE PUMP
RN1
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
TCON15
TCON14
TCON13
TCON12
TCON11
TCON10
TCON9
TCON8
TCON7
TCON6
TCON5
TCON4
TCON3
TCON2
TCON1
VDDP1
GNDP1
GPIO1/P01
GPIO0/P00
GPIO2/P02
RESET
PWM1D
PWM2D
TESTIN
POWER_ON_RST
1
TCON15
2
TCON14
3
TCON13
4
TCON12
TCON11
TCON10
R372
0/J/0402
R410
NC 0/F/0402
OEV1
R183
33/F/0402
R373
33/J/8P4R/2010
8
7
6
5
CLK1
CLK2
CLK3
POWER_ON_KEEPER (20)
INTBAT_DISCHG (15)
OEV1 (24)
RN3 33/J/8P4R/2010
1
8
LCD_ON_OFF (23)
CPV
2
7
3
6
4
5
0/J/0402
RN2
1
2
33/J/8P4R/2010 3
4
8
7
6
5
CLK1 (24)
CLK2 (24)
CLK3 (24)
STH2 (24)
STH1 (24)
OEH (24)
CPV (24)
STV2 (24)
STV1 (24)
VDDP
C291 0.1U/16V/0402
ON_STOP_OFF (20)
GPIO0
R192
I2C_INT (9)
0/J/0402
R196
R374
0/J/0402
R306
33/F/0402
R205
R200
47K/J/0402
External-BAT (15)
100K/J/0402
BATDET_SEL (15)
MRST (11)
LED_BRIGHTNESS (23)
4.7K/J/0402
C149
VCC5
B
VCC5
1U/16V/0603
R308
R489
R490
33/F/0402
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
R197 100K/F/0603
AVSS_ADC
VCLAMP
VRM
VRP
AVDD_ADC
C1NP
C1NM
YS1NP
YS1NM
CVBS1P
CVBS1M
AVDD_GMC
VIN_FB
OLPZ
IFB
VFB
AVDD_SAR
AVSS_SAR
AVSS_CCFL
AVDD_CCFL
Q2
Q1
VDDC1
AVSS_PWM
AVDD_PWM
PWMOUT2
FB2
SENSEN2
PWMOUT1
FB1
SENSEN1
CP2_FB
CP2_N
CP2_P
CP1_FB
CP1_N
CP1_P
REF_PWM
PGOOD
SAR0
SAR1
SAR2
SCK
SDI
SDO
CSN
PWM4D
INT
SDA
SCL
0.1U/16V/0402
AVDD_ADC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
C
AVDD_MPLL
AVSS_FSCPLL
HSYNCIN
VSYNCIN
XTALIN
XTALOUT
AVDD_DAC2
VCOMOUT
VCOMDC
VREP_DAC
VREM_DAC
AVSS_DAC2
VB
AVDD_DAC1
VG
AVSS_DAC1
VR
AVDD_OPLL
AVSS_OPLL
GNDC
VDDC2
ROM_EN
INTOUT
GNDP2
VDDP2
C
R195
U19
33/J/8P4R/2010
8
1 CE#
VDD
7
2 SO
HOLD#
6
3 WP#
SCK
5
4 VSS
SI
1
2
3
4
MX25L512
VDDC2
15 mil
R189 0/J/0402
AVDD_DAC
100
99
98
97
96
95
0.1U/16V/0402
C276
94
93
92
0.1U/16V/0402
C102
91
90
0.1U/16V/0402
C103
89
88
87
86
85
84
83
82
81
80
79
78
77
76
R188
C99
LED DRIVER
(3) AVIN_CVBS
R187 13/F/0402 R186 62/F/0402 C130 0.1U/25V/0603
CVBS1P
CSN
SDO
SDI_EEP_SDA
SCK_EEP_SCL
GND_A
AVDD_MPLL
15 mil
SERIAL FLASH
RN4
C100 20P/50V/0402
XTAL_IN
470P/50V/0603
C125 0.1U/25V/0603
Y1NM
D
VCC3_3
0.1U/16V/0402
R174
C275
R409
VCOMOUT (22)
VCOMDC (22)
VB
(24)
VG
(24)
VR
(24)
100P/50V/0402
C288
R166
15 mil
100P/50V/0402
C287
R408
(9)
1
R165 13/F/0402 R162 62/F/0402 C112 0.1U/25V/0603
C1NP
S_C
100P/50V/0402
C286
(9)
4
4.7K/F/0402_R
SCL_TX (24)
SCL_TX
SDA_RX
R211
100/F/0402
R212
100/F/0402
4.7K/F/0402_R
SCL
(6,8,9)
SDA
(6,8,9)
SDA_RX (24)
GND_A
R210
0/J/0402
IR_IN (9,24)
(25) PWM1
VOLUME (13)
CSN
SDO
SDI_EEP_SDA
SCK_EEP_SCL
(25) FB1
AVDD_PWM
R413
0/J/0402
(22) CP2_FB
(22) CP2_N
(22) CP2_P
(22) CP1_FB
(22) CP1_N
(22) CP1_P
(22) REF_PWM
A
R209
4.7K/J/0402
VCC5
C305
1U/16V/0603
BATLIFE_DET (15)
R214
R213
A
R483 0/J/0603
2K/F/0402 2K/F/0402
MENU_T (24)
5_DIR_KEY (24)
C170
0.1U/16V/0402
C169 R481
2.2K/J/0603
Title
0.1U/16V/0402
LCD BOARD
Size
Document Number
Custom
Date:
5
4
3
2
Rev
F
MST720A
Sheet
1
21
of
28
5
4
3
2
1
VGH
D
D
D18
D23
VCC5
BAT54SW
R320
BAT54SW
10mil
0/J/0402
0.1U/16V/0402
K
A
K
A
VCC15_VGH
C313
10K/F/0402
C302
R319
C299
220K/F/0603
0.1U/16V/0402
J
10U/16V/1206
CP1_FB (21)
J
R326
R321
C314
C318
C316
C311
20K/F/0603 0.1U/16V/0402
0.1U/16V/04020.1U/16V/04020.1U/16V/0402
(21) CP1_N
(21) CP1_P
C
C
D22
BAT54SW
VGL
D21
BAT54SW
D20
BAT54SW
R327
10mil
15K/F/0402
R323
A
K
A
K
A
K
VCCN10_VGLOUT
C317
0.1U/16V/0402
CP2_FB (21)
J
J
J
270K/F/0603
C312
10U/16V/1206
C310
C309
C308
C307
C306
C301
0.1U/16V/0402
0.1U/16V/0402
0.1U/16V/0402
0.1U/16V/0402
0.1U/16V/0402
R318
0.1U/16V/0402
(21) CP2_N
(21) CP2_P
(21) REF_PWM
30K/F/0603
B
B
C379
10U/16V/1206
R424
OP1
VCOM
VCOM (24)
0/J/0603
R287
R425
4.7K/F/0603
VCCP_VCOM
12K/F/0603
C380
R428
(21) VCOMOUT
4.7K/F/0603
10U/16V/1206
U11
1
2
3
4
OUT1
IN1IN1+
GND
V+
OUT2
IN2IN2+
UTC3308L
R431
VCC5
L14
8
7
6
5
2
SBK201209T-800Y-3
FB0805 1
R426
4.7K/F/0603
R427
560/F/0603
R429
R430
4.7K/F/0603
4.7K/F/0603
VCOMDC (21)
VCC_N4_5
100K/F/0603
A
A
Title
LCD BOARD
Size
Document Number
Custom
Date:
5
4
3
2
Rev
F
VGL,VGH,VCOM
Sheet
1
22
of
28
5
4
3
2
1
20V, 100mA LED Backlight
Iout = Vbrt / (3 x R128)
D
D
L16
NC
VIN_SYS
Q50
RSR020P03
S
D
A
K
CBC3225/4.7UH/1A
C332
R351
B140
G
R194
VCC_LED
D24
L12
C333
K
VCC12
R352
2.2U/25V/1206
10U/16V/1206
C334
C335
10U/35V/1210
0.1U/50V/0603
D26
100K/J/0603
200K/J/0603
B
R357
8
PMBS3904
FSEL
EN
SS
A
6
3
UDZSTE_17_24B
GND_DC
FB
R433
LED_FB (24)
100K/F/0603
COMP
R435
1
R358
4
9
E
C336
MP1542
0/J/0603_R
10K/J/0603
R438
R436
(21) LCD_ON_OFF
R349
Q25
2
3/F/0805
C
R437
3/F/0805
C
C
IN
7
SW
GND_DC
5
U24
100K/J/0603
GND
GND_T
100K/J/0603
NC
10N/50V/0603
C337
2.2N/25V/0603
0/J/0603
GND_DC
GND_DC
GND_DC
GND_DC
R439
165K/F/0603
LED_BRIGHTNESS (21)
GND_DC
LED POWER DRIVER
B
B
VEE_LCD
VDD_LCD
VCC5
R281
FB33
1A/600OHM/0603
FB34
1A/600OHM/0603
C260
C261
10U/10V/1206
0.1U/25V/0603
G
Q36
RSR020P03
S
D
4.7K/J/0402
C
GND_A
(21) LCD_ON_OFF
R362
4.7K/J/0603
Q35
B
E
PMBS3904
LCD POWER DRIVER
A
A
Title
LCD&LED POWER DRIVER
Size
Document Number
Custom
Date:
5
4
3
2
WDR830
SYSTEM
BOARD
Sheet
23
of
1
Rev
01
28
5
4
3
2
1
J12
VCC_LED
VCC_LED_T
1
TP164
1
TP161
5_DIR_KEY_T 1
TP152
LED_FB_T
IR_IN_T
VCC5_T
GND_A
VEE_LCD_T
VB_T
TP151
TP147
TP148
TP144
TP145
C354 20P/50V/0402
C355 20P/50V/0402
VG_T
VR_T
1
1
TP136
TP137
C356 20P/50V/0402
C357 20P/50V/0402
CLK1_T
CLK2_T
1
1
TP133
TP134
C358 20P/50V/0402
C359 20P/50V/0402
CLK3_T
STH1_T
1
1
TP131
TP132
C360 20P/50V/0402
C361 20P/50V/0402
STH2_T
OEH_T
1
1
TP128
TP129
C362 20P/50V/0402
C363 20P/50V/0402
MOD_T
VCOM_T
1
1
TP125
TP126
C364 20P/50V/0402
C365 20P/50V/0402
OEV1_T
CPV_T
1
1
TP122
TP123
C366 20P/50V/0402
C367 20P/50V/0402
STV2_T
STV1_T
1
1
TP120
TP121
(21) VB
(21) VG
(21) VR
C368 1U/16V/0603
C369 1U/16V/0603
VCC15_VGH_T 1
TP117
VCCN10_VGLOUT_T1
TP119
C370 20P/50V/0402
VDD_LCD_T
GND
MENU_T_T
GND_DC
1
1
1
1
TP124
TP127
TP23
TP155
EXTCHG_VCC_T 1
C372 1U/16V/0603
C373 1U/16V/0603 BATFAIL_DET_T 1
TP158
TP162
VDD_LCD
(21) CLK1
(21) CLK2
(21) CLK3
(21) STH1
(21) STH2
(21) OEH
VDD_LCD
C22
C21
MRST
POWER_SWITCH
POWER-KEY
MENU_T
1
1
1
1
1
20P/50V/0402
20P/50V/0402
20P/50V/0402
A
20P/50V/0402
VC3
SWITCH CON
0/J/0402
0/J/0402
0/J/0402
0/J/0402
R385
VDD_LCD_T
0/J/0402
R386
0/J/0402
CLK1_T
CLK2_T
R387
0/J/0402
R388
0/J/0402
CLK3_T
R389
0/J/0402
STH1_T
STH2_T
R390
0/J/0402
R391
0/J/0402 OEH_T
R392
4.7K/J/0402 MOD_T
L_R_T
R360
4.7K/J/0402
R393
0/J/0402 VCOM_T
R394
0/J/0402 OEV1_T
UD_T
R395
0/J/0402 CPV_T
STV2_T
R396
0/J/0402
R397
0/J/0402 STV1_T
R398
0/J/0402
VCC15_VGH_T
R399
0/J/0402 VCCN10_VGLOUT_T
R400
0/J/0402
NC
J13
DEBUG CON
GND_POWER
TP32
TP34
TP4
TP160
TP10
SDA_RX
SCL_TX
DGND
+5V
1
TP180
4
PANEL CON
Title
VCC5
TP182
TP183
3
B
A
LCD BOARD
TP181
1
1
C
0/J/0402
SCL_TX (21)
1
D
R361
SDA_RX (21)
4
3
2
1
Size
A4
Date:
5
GND_A
VEE_LCD_T
VB_T
VG_T
VR_T
G2
G1
GND_P8
GND_P7
VCC_LED2
VCC_LED1
GND_P6
LED_FB2
LED_FB1
GND_P5
GND_P4
GND_P3
GND_P9
LED_R
LED_P
EJECT
5DIR_KEY
IR_IN
VCC5
GND_P2
GND_P1
AVSS
AVDD
VB
VG
VR
GND2
VCC2
CPH1
CPH2
CPH3
STHR
STHL
OEH
MOD
L/R
VCOM2
VCOM1
OEV
U/D
CKV
STL
STR
VGH
VGL
VCC1
GND1
20P/50V/0402 C105
C23
BOTMRST (11)
POWER_SWITCH (20)
POWER-KEY (20)
MENU_T (21)
C148
MRST
POWER_SWITCH
POWER-KEY
MENU_T
20P/50V/0402
0/J/0402
0/J/0402
0/J/0402
0/J/0402
C24
R381
R382
R383
R384
20P/50V/0402 C147
20P/50V/0402 C142
20P/50V/0402 C141
20P/50V/0402 C139
20P/50V/0402 C138
20P/50V/0402 C136
20P/50V/0402 C135
20P/50V/0402 C132
20P/50V/0402 C131
20P/50V/0402 C127
20P/50V/0402 C126
20P/50V/0402 C123
20P/50V/0402 C122
20P/50V/0402 C120
20P/50V/0402 C119
20P/50V/0402 C116
20P/50V/0402 C115
20P/50V/0402 C111
20P/50V/0402 C110
GND_POWER
J3
20P/50V/0402
TP167
TP168
C154
1
1
VC2
NC
R401
R402
R403
R404
BATFAIL_DET_T
EXTCHG_VCC_T
MENU_T_T
5_DIR_KEY_T
IR_IN_T
VCC5_T
10mil
L_R_T
UD_T
5
4
3
2
1
LED_FB_T
(21) CPV
(21) STV2
(21) STV1
VCC15_VGH
VCCN10_VGLOUT
B
REST
P_SW2
P_SW1
MENU
GND
FB46 1A/390OHM/0603
(22) VCOM
(21) OEV1
20P/50V/0402
C371 20P/50V/0402
VCC_LED_T
VEE_LCD
C158
C
FB45 1A/390OHM/0603
R376
0/J/0402
R377
0/J/0402
R378
0/J/0402
R379
0/J/0402
R380
0/J/0402
FB51 1A/390OHM/0603
(18) BATFAIL_DET
EXTCHG_VCC
(21) MENU_T
VCC5 (21) 5_DIR_KEY
(9,21) IR_IN
20P/50V/0402
C155
20P/50V/0402
C152
C352 20P/50V/0402
C353 20P/50V/0402
1
1
1
1
1
20P/50V/0402
C350 20P/50V/0402
C351 20P/50V/0402
LED_FB
(23) LED_FB
C172
C349 20P/50V/0402
20P/50V/0402
C344 20P/50V/0402
D
GND_DC
C168
C343 20P/50V/0402
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
2
Document Number
Rev
F
Connector
Sheet
24
1
of
28
5
4
3
2
1
AVDD_DAC
+5V_SYS
VCC5
R292
4.99/F/0603
TC30
-5V
D
AVDD_PWM
NC
VCC_N4_5
D17 BAT54SW
A
0.1U/25V/0603
J
C315
R310
R312
D
2/F/0603
30/F/0402
GND_A
C295
AVDD_CCFL
C300
10U/6.3V/0805
R301 4.99/F/0603
1U/16V/0603
K
C296
GND_DC
GND_DC
NC
VCC5
Q42
RSR020P03
S
D
VCC2_5
L10
+2.5V
AVDD_GMC
K
C319
G
C320
R324
TC11
CBC2016/22UH
C304
R317
D19
10U/10V/0805 0.1U/25V/0603
R299
4.99/F/0603
R300
2/F/0603
0.1U/25V/0603
B0520LW
100U/6.3V/B
510/F/0402
33/F/0402
A
FB1
GND_DC
(21)
R316
GND_DC
C
(21) PWM1
VDDP
C
470/F/0402
GND_DC
GND_DC
+3.3V_SYS
OUTPUT CONTROL by M720
VCC3_3
R303
NC
VCC2_5
AVDD_OPLL
FB55
BK1005HS330
AVDD_MPLL
FB56
BK1005HS330
B
B
AVDD_ADC
R293 4.99/F/0603
TC31
VDDC1
R313
47U/6.3V/B_R
0/J/0603
GND_A
VDDC2
VCC2_5
R289
0/J/0603
A
A
Title
M720 POWER
Size
Document Number
Custom
Date:
5
4
3
2
Rev
01
Power
Sheet
1
25
of
28
7.0 ELECTRICAL
DIAGRAM4
5
3
2
1
D
D
+3.3V_SYS
TC38
47U/6.3V/A
2
1
FB43
1A/600OHM/0603
C402
0.1U/50V/0603
C418
100P/50V/0603
30mA
C338
10U/10V/0805
C403
0.1U/50V/0603
2
R364
1K/F/0402
1
C
GNDV
C
C
GND_DC
C339
22P/50V/0603
Q51
B
E
PMBS3904
FB54
1A/600OHM/0603
AVOUT_CVBS (3)
E
L13
2.2UH/50mA/2520
B
(9) 8380_CVBS
Q52
PMBS3906
2
R368
75/F/0402
C
2
C341
47P/50V/0603
R371
100/F/0402
C342
22P/50V/0603
1
1
B
GNDV
GNDV
GNDV
B
GNDV
GNDV
A
A
Title
Video buffer
Size
A
Document Number
Date:
5
4
3
2
Rev
F
Sheet
26
of
1
28
5
4
3
2
TBD4
0/J/0805
1
TBD20
NC
TBD21
NC
TBD22
NC
TBD23
NC
TBD24
NC
TBD25
NC
TBD32
NC
GND_RF
TBD2
NC
D
P2
P3
D
P1
TBD26
NC
TBD27
NC
TBD28
NC
TBD29
NC
TBD30
NC
TBD31
NC
1
1
1
GND_SIGNAL
GND_SIGNAL
bridge
TBD3
BCF-35320A
GND_DC
TBD6
0/J/0805
P5
GND_POWER
GND_SIGNAL
GND_DC
GND_SIGNAL
1
GND_SIGNAL
bridge
TBD16
BCF-35320A
C
GND_DC
bridge
TBD8
BCF-35320A
R475
0/J/0603
C
TBD1
0/J/0805
GND_SIGNAL
TBD18
NC
R476
0/J/0603
R485
0/J/0603
R486
0/J/0603
GNDV
GND_DC
TBD19
NC
GND_POWER
GNDM
R484
0/J/0603
TBD17
NC
GND_SIGNAL
TBD15
NC
R480
0/J/0603_R
GND_POWER
GND_POWER
GND_SIGNAL
GNDV
GND
GND_RF
GND_SIGNAL
B
B
R440
R443
R298
0/J/0603_R
0/J/0603_R
0/J/0603
R441
R444
R325
0/J/0603_R
R442
0/J/0603_R
R445
0/J/0603_R
R446
0/J/0603_R
0/J/0603_R
0/J/0603
A
A
GND_A
Title
GND_A
GND_DC
Size
A4
Date:
5
4
3
2
Document Number
Rev
F
WDR830 Main Board
Sheet
27
1
of
28
8.0 EXPLODED VIEW DIAGRAM & SERVICE PART LIST
Electrical Part list:
360
300
100
310
Pos No.
100
110
120
141
142
12NC
996510001019
996510001020
996510001021
996510001022
996510001023
Description
MAIN PCBA
3-IN-1 KEYPAD PCBA
TOP KEYPAD PCBA
FFC 5PIN P=0.5 L=80 LINK KEYPAD
FCC 45PIN P=0.5 L=140 LINK TUNER
Mechanical Part list:
210
330
500
200
320
360
220
Pos No.
200
210
220
300
310
320
330
340
350
360
370
500
12NC
996510001024
996510001025
996510001026
996510001027
996510001028
996510001029
996510001030
996510001031
996510001032
996510001033
996510001034
996510001035
Accessories Part list:
Pos No.
12NC
996510001049
996510001052
110
Description
TFT LCD
DVD LOADER
SPEAKER ASSY(IN PAIR)
FRONT CABINET ASSY
JOGGING BUTTON
CONDUCTIVE FABER TUNER BOARD
SPONGE LCD PANEL
WIRE 1.0MM PITCH 2P/155MM BLACK
WIRE 1.0MM PITCH 2P/195MM WHITE
BACK CABINET ASSY
RUBBER HEAT CONDUCTOR
BATTERY ASSY
ACADAPTOR
996510001041
996510001051
996510001050
120
CARADAPTOR
RC
RCA CABLE
BAG
CARMOUNT
996510001036
996510001037
996510001038
996510001039
996510001040
Description
AD/DC ADAPTOR AY4129/00 (FOR
PET830/00 & PET830/58)
PET830/05)
PET830/37)
PET830/44)
PET830/75)
CAR ADAPTOR
REMOTE CONTROL
RCA CABLE
CARRY BAY (POUCH)
CAR MOUNT EXT ASSY
9.0 REVISION LIST
Version 1.0 (3141 785 31570)
• Initial release PET830/00/05/37/44/58/75

Service Manual - Mandos a Distancia

Transcription

Similar documents

Standard schematic diagrams

DVD GAME/GAME USB

CED750 service manual