Service Manual - Michael Jay Lissner

Transcription

Service Manual
ViewSonic PJ402D-2
Model No. VS10400
DLPTM Projector
(PJ402D-2_SM Rev. 1e Dec. 2008)
ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583
Copyright
Copyright ¤ 2007 by ViewSonic Corporation. All rights reserved. No part of this publication may be
reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language or
computer language, in any form or by any means, electronic, mechanical, magnetic, optical, chemical,
manual or otherwise, without the prior written permission of ViewSonic Corporation.
Disclaimer
ViewSonic makes no representations or warranties, either expressed or implied, with respect to the
contents hereof and specifically disclaims any warranty of merchantability or fitness for any particular
purpose. Further, ViewSonic reserves the right to revise this publication and to make changes from time
to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or
changes.
Trademarks
Optiquest is a registered trademark of ViewSonic Corporation.
ViewSonic is a registered trademark of ViewSonic Corporation.
All other trademarks used within this document are the property of their respective owners.
Revision History
Revision
SM Editing Date
1a
12/20/05
1b
Documents Number
DCN Number ECR Number
Description of Changes
Editor
Initial Release
BonnieT.
5/30/06
RoHS issue(revise RSPL, add BOM list of page 66-74)
BonnieT.
1c
7/13/06
Replace the photos to be clear to read.
BonnieT.
1d
1/10/07
Add content of reset the lamp hours (Appendix)
Sophia Kao
1e
12/15/08
RSPL update
Sophia Kao
5755
VS-E080372
Confidential - Do Not Copy
ViewSonic Corporation
i
PJ402D-2
TABLE OF CONTENTS
1. Precautions and Safety Notices ………………………………………1
2. System Introduction……………………………………………………2
3. Firmware Update……………………………………………………….9
4. Machine Dissassembly and Replacement………………………….11
5. Trouble shooting……………………………………………………….23
6. Connector Information………………………………………………...33
7. FRU(Field Replaceable Unit) List…………………………………… 43
8. Basic Circuit Diagrams……………………………………………….. 47
9. Recommended Spare Parts List…………………………………….. 65
10. Appendix....................................……………………………………75
ii
PJ402D-2
Chapter 1
Precautions and Safety Notices
1. When replacing the lamp, use care to avoid burns to your fingers. The lamp becomes very hot
during operation.
2. Never touch the lamp with your fingers as body oil transferred to the lamp can damage the
lamp’s useful life.
3. Never drop the lamp or jar it in any manner. This may cause the lamp to burst.
4. This projector is provided with a high voltage circuit for the lamp. Do not touch any electric
part or component after the projector has been turned on and is operating. Doing so could
induce a severe shock causing injury or death.
5. Do not touch the exhaust fan, nor block its air flow, during operation, as the fan is hot.
6. Use only the cables which are included with the projector, or are specified in this manual.
7. Ensure that screws are tightened properly. Screws not tightened fully may result in injury or accidents.
8. Since the lamp is made of glass, do not drop the unit and do not scratch the glass.
9. Do not reuse the old lamp. This could cause the lamp to explode.
10. Be sure to turn off the projector and unplug the AC power cord before replacing the lamp.
11. Do not use the projector with the lamp cover removed.
Disposal :
For disposal of spent lamps, always consult federal, state, local and
provincial hazardous waste disposal rules and regulations to ensure
proper disposal.
Caution :
This lamp emits ultra violet (UV) radiation and operates at high
pressure.
This lamp may only be used in enclosed fixtures that comply with
UL1572.
Due to the high luminous efficacy, the UV radiation which the lamp
emits and the high pressure within the lamp, P-VIPâ lamps may only be
operated within enclosed, purpose-built housings.
1
PJ402D-2
Chapter 2
System Introduction
Technical Specification
Item
Description
Display Type
Single Panel 0.55" DLP Projector
Lamp Type
NUP 200W
Resolution(Pixels)
786,432 dot x1 (1024 x 768 x1)
Optical Compensation
Light Tunnel
Screen Size
31~312 inches
Projection Type
Front, Rear, Ceiling
"Horizontal frequency (31~79KHz" )
Compatibility
"Vertical frequency ( 50~85Hz" )
Pixel Rate 108 MHz
Keystone Correction
Vertical: +/-15
Audio System
2W x 1
Aspect Ratio
1:1 , 16:9 , 4:3
Video Input
PAL , NTSC , SECAM
Input Source
Computer , HDTV , S-Video , Video
Analog RGB (Input Signal)
D-Sub Connector
2
PJ402D-2
Item
D escription
3:2 Pull D own
Progressi ve Scan
Blank
Other Key Features
Auto Source D etecti on
Freeze
Auto Tracki ng/Sync.
Plasti c Body
Power Requi rement
100~240v, 50~60Hz
Dimensions(WxDxH)
254 x 202 x 98 mm
Weight
2.2 KG (<4.9 lb)
Remote Mouse
Multi functi onal
OSD Language
Chinese, English, French, German, Spanish,
Itali an, Portuguese, Russi an, Japanese, Korean
Power C onsumpti on
250 W
Operation AC Temperature Range
+5 ~ +35C
Power Supply
AC 100 - 240 V , 50 - 60 Hz
3
PJ402D-2
Lamp Specification
1.Scope
The product is a lamp system consisting of a short arc burner with a reflector and an electric
lamp ballast.
2. Product : NSH200PT
Product name:Short arc mercury lamp with reflector
USHIO type
NSH200PT (see Figure 3.)
3. Application
Back lighting for DMD projector
4. Appearance, Structure and dimension
Appearance:
There must not be any defect which deviates from initial charactertics showing in
Table 1.
As for scratches, coating peeling, dirt and on reflector or lamp, whether defective or
not is to be judged by the initial characteristics shown in the Table 1.
5.Initial characteristics
Initial lamp bulb characteristics:
Initial lamp bulb characteristics:
Characteristics should satisfy the values of table 1, when lamp is operated to optical
bench specified under figure 1.
4
PJ402D-2
System Block Diagram
7
PJ402D-2
Optics-Conceptual Drawing
8
Confidential – Do Not Copy
PJ402D-2
Chapter 4
Machine Disassembly and Replacement
This section provides disassembly procedures for PJ458D DLP Projector. Before you begin
any of these procedures, be sure to turn off the power, computer system, and other attached
devices; then disconnect the power cable from the electronically outlet. Moreover, when you
disassemble the projector, be sure to put the screws in a safe place and separate them according to grouping.
Tools Needed
Item
PHOTO
Long Nose Nipper
Hex Sleeves 5mm
Screw Bit (+) : 107
Screw Bit (+) : 101
Screw Bit (+) : 102
General Information
Before You Begin
Before proceeding with the disassembly procedure, make sure that you do the following:
1. Turn off the power to the system and all peripherals.
2. Unplug the AC adapter and all power and signal cables from the system.
3. Weary grended Anti-static wrist strap.
11
PJ402D-2
Disassemble Lamp Module
Note:Unplug all the cords before disassembling the Projector.
1.
2.
3.
4.
Loosen two screws of Lamp Cover.
Remove Lamp Cover.
Loosen two screws of Lamp Module.
Grasp the lamp handle and pull out Lamp Module.
p.s Related notice of replace went lamp please refer to the Lamp Specification section .
J1635-3660-00
J1635-3660-00
P4184-2400
12
PJ402D-2
Disassemble Front & Top Cover
1.
2.
3.
Turn over the Projector.
Remove four 4 screws on bottom cover.
Remove the front cover set.
J1635-3670-00 x 2
J1635-C98-N
1.
2.
Remove the 4 screws of back cover.
Life up top cover directly (Be careful there is a internal wire connected with the main board).
P3484-1003
J1635-B770-00
J1635-C98-N
13
PJ402D-2
Disassemble Key Pad , Speaker & Front IR Board
1.
2.
Remove all screws of top cover.
Life up all components including key pad, speaker , front IR board.
02595-0014-00
J1635-3610-00
x7
01635-361 *7
Disassemble Front Fan
1.
Lift up the fan set directly .
P1643-0021
14
PJ402D-2
Disassemble Main Board
1.
2.
3.
Remove the five screws of main board .
Unplug all wires on the board (Main Board PIN location of connectors please refer to
Chapter 5 )
Remove the Main Board.
J1635-3660-00
P4184-1010
J1635-3660-00
15
PJ402D-2
Disassemble IO Cover and Video Baord
1.
2.
Unscrew two screws of the IO cover.
Separate all parts individually .
16
PJ402D-2
Disassemble Ballast Module
1.
2.
3.
Unplug all wires on Ballast Module (Ballast Board PIN location of connectors : please refer
to Chapter 5 )
Unscrew four screws on Ballast Module.
Remove the Ballast Module.
01635-361 *2
01635-366 *2
P1643-0016
Unscrew then lift up the IR board
01635-A44-N *4
P1647-9000
P1638-152
P1635-055
17
PJ402D-2
Disassemble Optical Engine
1.
2..
3.
4.
Unplug the wire inside.
Unscrew four screws on Optical Engine.
Then remove the Engine Module.
Be careful and don’t drop the Engine due to the heavy weight.
P1635-600
P1638-102
Unscrew three screws then remove the fan .
P1643-0020
P0335-101 *3
18
PJ402D-2
Disassemble Power Outlet Set
1.
2.
Remove the screw from the bottom of power wires and unplug the connector.
Then lift up the power outlet set.
19
PJ402D-2
Disassemble Power Board
1.
2.
3.
Unplug all the wires on the board (Power Board PIN location of connectors: please refer to
Chapter 5 )
Unscrew five screws on Power Board.
Then remove Power Board.
20
PJ402D-2
Disassemble Foot Screw Assembly
1.
2.
3.
Push buttom let foot screw assembly fall off.
Use nipper or tweezers carfully to press the head of foot screw .
Then foot screw assembly drop out by itself .
82134-465
82135-351
82134-464-99
P1634-466
21
PJ402D-2
Exploded overview
Ballast exploded overview
22
PJ402D-2
Chapter 5
Troubleshooting
This chapter provides technicians and people who have an electronic background a primary
description about maintaining the product. Moreover, you can get the appropriate operation
to solve some complicated problems of component repairing and professional problems.
The Troubleshooing section focus on:
1.
Video Signal Troubleshooting
2. Operation Function Troubleshooing
3.
Power Source Troubleshooting
23
PJ402D-2
Video Signal
Video
No Signal
Computer
No Signal
Check
Source
NG
Check
Source
Turn on
Source
NG
Replace
Cable
Check
Cable
NG
Video
Mode
Input
NG Change to
Replace
Cable
OK
OK
Computer
Mode
Input
Turn on
Source
OK
OK
Check
Cable
NG
NG
Change to
Computer
Mode
OK
OK
Change Main
Board
Change Main
Board
Video Mode
24
PJ402D-2
Fail to light up
OK
Check
LED indication
NG
Look up user
manual ,and
follow indicated action
Check
Optical Engine
NG
Replace Optical
Engine
OK
Check
Lamp
NG
Replace Lamp
OK
Check
Fan
NG
Replace Fan
OK
Check
C/W wire loose or
not
NG Connect C/W
cable completely
OK
Check
Ballast
NG
Replace
Ballast
NG
Replace Main
Board
OK
Check
Main Board
25
PJ402D-2
Color Missing
On Screen
No Volume
Check
source and mute
function
NG Input the correct
Check
Cable
source to Projector
OK
Check
Top cover’s cable
NG Replace cable
C/W Sensor
Cable
Connector
or connect the
cable back
Cable
NG
Check C/W Sensor
Cable Connector
became loose or
not
OK
NG
Speaker
Connector
Became loose
Check Main
Board
NG Change Main
Board
OK
OK
Check
Speaker
Replace
OK
OK
Check
Speaker
Connector
NG
NG
Change Optical
Engine
Replace
Speaker
OK
Check
keypad
NG
Replace keypad
OK
Check
Main
Board
NG
Replace Main
26
PJ402D-2
Operation Function:
Remote Control
Failure
Check
Battery
Level
Button Failure
NG
Check
Top cover’s cable
Replace Battery
NG Replace Remote
Check
Button
Control
NG
Replace Button
OK
OK
Check
IR Board or IR cable
or connect the
cable back
OK
OK
Check
Remote
Control
NG Replace cable
NG Replace IR
Check
Keypad
Board or IR
cable
OK
NG
Replace Keypad
OK
Replace
Main Board
Main
Board Fail
27
PJ402D-2
Power Source:
No Power Source
After Turning On
Check
Power Cord
Fan failure After
Turning On
NG
Check
Fan
Connector
Replace
Power Cord
OK
Check
Lamp Cover
Switch
NG Replace Lamp
Cover or
Reassembly
NG Replace
Check
Fan
keypad
cable...
NG
Replace Inner
Wires
NG
R e p l ac e
Fan
OK
NG Replace
Power Board
wire
Check
Main
Board
NG
Replace
Main Board
OK
OK
Check
Main
Board
Check
Inner
Wires
OK
OK
Check
Power
Board wire
Fan Connector
Became loose
OK
OK
Check
Top Cover (keypad
cable...)
NG
NG Replace Main
Board
Replace Power
Baord
OK
Check
Power
Board
NG Replace
Power Board
28
PJ402D-2
Function Test and Alignment
Equipment Needed
Item
Description
1
PC with SVGA resolution (Color Video Signal & Pattern Generator)
2
Remote Controller
3
Test Cable
4
Power Cord
5
DVD Player
Test Condition
Item
Description
1
Circumstance Brightness : Dark room less than 60 lux
2
Inspection Distance : 1.8m
3
Screen Size : 60 inches diagonal (wide)
4
Before function test and alignment, each PJ458D should be run-in and
warmed-up for at least 5 minutes with following conditions.
1.) In room temperature
2.) With cycled display colors (R,G,B,White)
3.) With cycled display modes
640 x 350 (H=31.5 KHz, V=70 Hz)
640 x 400 (H=31.5 KHz, V=70 Hz)
640 x 480 (H=37.5 KHz, V=75 Hz)
720 x 400 (H=31.5 KHz, V=70 Hz)
800 x 600 (H=53.7 KHz, V=85 Hz)
800 x 600 (H=37.9 KHz, V=60 Hz)
1024 x 768 (H=48.4 KHz, V=60 Hz)
1024 x 768 (H=68.7 KHz, V=85 Hz)
5
Test Display Mode and Pattern
29
PJ402D-2
Test Display Modes and Patterns
Compatible Modes
Preset Signal
VGA
SVGA
XGA
S yn c
H(+), V(-)
H(-), V(+)
H(-), V(-)
Resolution
H(-), V(-)
fH(Hz )
Siz e
59.94
31.469
800
72.809
37.861
832
75
37.5
840
85.008
43.269
832
56.25
35.156
1024
60.317
37.879
1056
72.188
48.077
1040
75
46.875
1056
85.061
53.674
1048
60.004
48.363
1344
70.069
56.476
1328
75.029
60.023
1312
84.997
68.677
1376
70.016
63.995
1472
75
67.5
1600
85.057
77.487
1568
60
60
1800
75
75
1680
60.02
63.981
1688
640 x 800
800 x 600
1024 x 768
H(+), V(+)
SXGA
fV(Hz )
1152 x 864
H(-), V(-)
H(+), V(+)
SXGA
1280 x 960
H(+), V(+)
SXGA
H(+), V(+)
1280 x 1024
30
PJ402D-2
Function Test Display Pattern
Item
1
2
3
Test C ontent
Noi se check up
D ust check up
D ust check up
Pattern
Specification
R emark
12 squares
(1).Select the "12 squares" BMP
fi le to check i f there i s any
noi ses duri ng the stage of
turni ng on, and warmi ng up the
projector.
Fi gure 1
12 squares
(2). The noi ses appear on the
square should be less than
three squares.
Fi gure 1
800 fli cker
(3).Select the " 800 fli cker" BMP
fi le. Make sure teach word on
the projected i mage doesn not
fli cker.
Fi gure 2
Full Black
(1) Select the " Full Black" BMP fi le
to project the i mage on the
Fi gure 3
screen .Stand 1.8 meters from i t
and ensure there are no stai ns .
Full Whi te
(1) Select the " Full Whi te" BMP fi le
Fi gure 4
(1) Select the " black and whi te
word" BMP fi le. Use the
projector to adjust the projected
i mage to the maxi mum si ze
and mi ni mum si ze and make
sure each word i s
di sti ngui shable under both
condi ti ons.
Fi gure 5
Fi gure 6
4
Resoluti on check up
Black and
Whi te Word
5
RGB color check up
256RGB
(1) Select the "256RGB" BMP fi le
to check i f the color ladder of
the i mage matches the color
ladder of the fi le.
Full Gray
(1) Select the " Full Gray " BMP fi le
Fi gure 7
Boundary
Frame
(1) C li ck on the folder, select the "
Boundary Frame " BMP fi le,
press the AUTO button on the
projector, check i f the li nes and
colors of the projected i mage
are clear as presented on the
BMP fi le .
6
7
D ust check up
Li ght leakage check
up
Fi gure 8
31
PJ402D-2
Full Black Pattern (Figure 3)
Full White Pattern (Figure 4)
Black and White Word Pattern (Figure 5)
256RGB Pattern (Figure 6)
Gray Pattern (Figure 7)
Boundary Frame (Figure 8)
32
PJ402D-2
Chapter 6
Connector Information
Introduction
This section provides each connector location on boards, signal and function of each
board. They will be useful for your detecting the defective boards.
Main Board
Summarize
C onnector
D escription
C N1
IR
C N2
Keypad control
C N3
F an
C N4
F an
C N5
F an
C N6
F an
C N7
IR
J1
Ballast control
J2
Thermal
J3
Vi di o & S-Vi deo i n
J5
D MD connector
J7
Phone jack stereo-R
J8
C olor wheel
J9
Power i n
J1 5
Vi di o & S-Vi deo i n
JP 1
USB
JP 3
C W i ndex
JP 4
Fi rmware debug
JP 5
Standby run
C ON1
D -SUB
C ON2
V i deo
C ON3
S-vi deo
33
PJ402D-2
The Locations of Connectors
CN1 , CN7 : IR
CN3 , CN4 , Cn5 : FAN
J1 :Ballast Control
34
PJ402D-2
CN2 : Keypad Control
35
PJ402D-2
J2 :Thermal
J3 , J15 : Video & S-Videop IN
CON2 : Video
CON3 : S-Video
36
PJ402D-2
CON1 : D_SUB
J7 : Phone jack Stereo-R
J8 : Color Wheel
37
PJ402D-2
J9 : Power Supply
JP1 : USB
JP3 : CW Index
JP3 : CW Index
38
PJ402D-2
JP4 : FirmWare Debug
39
PJ402D-2
Power Board
Summarize
CN101 : AC Inout
40
PJ402D-2
CN201 : +380V Output
CN301 :DC Output
41
PJ402D-2
Ballast Board
Summarize
W03 : Lamp Signal
CN100 : 380V
CN100 : 380V
42
PJ402D-2
Chapter 7
FRU (Field Replaceable Unit) List
This chapter gives you FRU ( Field Replaceable Unit ) listing in global configuration of PJ458D
Refer to this chapter whenever ordering parts to repair or for RMA ( Return Merchandise
Authorization ). Please note that WHEN ORDERING FRU PARTS, you should check the most
up-to-date information available on your regional web or channel. For whatever reasons a part
number change is made, it will not be noted on the printed Service Guide. For ViewSonic AUTHORIZED SERVICE PROVIDERS, ViewSonic office may have a DIFFERENT part number code
from those given in the FRU list of this printed Service Guide. You MUST use the local FRU list
provided by your regional ViewSonic office to order FRU parts for repair and service of customer
machines.
NOTE : To scrap or to return the defective parts, you should follow the local government
ordinance or regulations on how to dispose it properly, or follow the rules set by your
regional ViewSonic office on how to return it.
43
PJ402D-2
FRU List
No
Part Name
Part Number
1
Main Board
P3584-1002
2
Ballast Board
P4184-1001
3
Power Board
P4184-1007
4
Keypad
P4184-1006
5
Front IR Board
P3247-5100
6
Back IR Board
P3247-5101
7
Top Cover
P3484-1003
Photo
44
PJ402D-2
No
Part Name
Part Number
8
Bottom Cover
P1684-0004
9
Front Cover
P3484-1002
10
Front IR Cover
P1634-461-99
11
IO Cover
P1634-465-99
12
Foot Screw
P1643-0012
13
Optical Engine
P4184-1008
14
Lamp Module
P4184-1005
15
Fan x 1
02394-0011-01
Photo
45
PJ402D-2
No
Part Name
Part Number
16
Fan x 2
P1643-0021
17
Speaker
02413-0016-00
18
FFC Cable
02591-0014-00
19
Wire 4P C/W
02595-0018-00
20
Wire 3P IR/F
02595-0016-00
21
Wire 3P IR/B
02472-0016-00
22
Wire 5P BST
02595-0030-00
23
Wire 2P 380V
02595-0019-00
24
Wire 12P-10+2P PWB
02595-0063-00
25
Wire 2P AC Socket
02595-0028-00
Photo
46
PJ402D-2
Chapter 8
Basic Circuit Diagrams
BLOCK DIAGRAM
USB
JP1
U5_1 <AD9883>
VGA
48BIT R/G/B
RGB+HV
A/D CONVERTER
CON1
Composite
Y/C
DMD INTERFACE
U6_1 <VPX-3226E>
16BIT YUV
CON2
S-VIDEO
CVBS
SCALER
VIDEO DECODER
U1_1 < DDP 2000>
PWM TO DC
CON3
FAN x 3
U14
FLASH MEMORY
U6_2 <TPA0172>
AUDIO IN
CVBS
SPEAKER
AUDIO PROCESSOR
INPUT FORM
POWER SUPPLY
J7
+3.3V
+5VS
+2.5V
+5V
+13.8V
+12V
+3.3V
DC / DC POWER
+2.5V
+1.5V
47
PJ402D-2
JP5_1 <WR-120S-VFH30-1>
AD9883
AVDDV
4
TAB
C168
10uF
+ TANAD
C167
0.1uF
C97
0.1uF
C93
10uF
+ TANAD
4
TAB
+5V
V33
U27
AIC1117-3.3/TO252
02037-0BZ O
VI
VO
C271
10uF
+ TANAD
C267
C98
10uF
+ TANAD
C99
0.1uF
I
PVDDV
U30
AIC1117-3.3/TO252
02037-0BZ O
VI
VO
ADJ
I
ADJ
0.1uF
4
TAB
C132
C273
10uF
+ TANAD
0.1uF
C181
C180
C189
C154
C190
C281
C169
C278
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF0.1uF
close to AD9883
GND
A
C129
10uF
+ TANAD
02237-512
+5V
A
C112
0.1uF
AVDDV
U9
AIC1117-3.3/TO252
02037-0BZ O
VI
VO
ADJ
I
A
+5V
PVDDV
V33
C123
0.1uF
C275
0.1uF
C292
C121
0.1uF
0.1uF
C279
C122
C276
C216
0.1uF
0.1uF
0.1uF
0.1uF
02237-C05
VVCC
02137-8H5
PVDDV
R101
4K7
02137-8H5
VFILT
ZD1
5.6V/NC
33
AVDDV
SOGIN
GND
VDC5V
5,13,16,17 SDA0
5,13,16,17 SCL0
16
L23
1
11
6
2
12
7
3
13
8
4
14
9
5
15
10
VGREEN
FB_30_OHM_500MA
FB_30_OHM_500MA
HSYNC
R168
75
49
22PF
C341
17
22PF
GND
GND
R273
02137-8RJ
75
22PF
C342
VSCL
ALF_HSYNC
ALF_VSYNC
30
31
1.5K
R169
C343
68PF
75
GND GND
GND
GND
VREFBYP
VMIDSCV
58
37
C147
C141
0.1uF
GND
VVCC
2
2
BAV99L
BAV99L
1
3
GND
D10
GND
D11
1
GND
1
GND
GND
U34
74HC1G125
C338
22
4
2
SOT23-132
R185
AD_VSYNC
ALF_VSYNC
ALF_VSYNC
4
ALF_HSYNC
ALF_HSYNC
4
L33
FB_30_OHM_500MA
R176
2
C340
22PF
GND
GND
48
U28
GND
22
02137-8M0
PJ402D-2
AD_HSYNC
1
22PF
L32
FB_30_OHM_500MA
34
35
26
27
77
76
75
74
73
72
71
70
9
8
7
6
5
4
3
2
19
18
17
16
15
14
13
12
67
PR8 8
7
VGR0
6
VGR1
5
VGR2
4
VGR3
3
VGR4
2
VGR5
1
VGR6
PR10 8
VGR7
7
6
VGG0
VGG1
5
VGG2
4
VGG3
3
VGG4
2
VGG5
1
VGG6
PR13 8
VGG7
7
6
VGB0
5
VGB1
4
VGB2 3
VGB3 2
VGB4 1
VGB5
VGB6
VGB7
9 33,1/16W,5%
10 02137-927
11
12
13
14
15
16
9 33,1/16W,5%
10 02137-927
11
12
13
14
15
16
9 33,1/16W,5%
10 02137-927
11
12
13
14
15
16
R60
R59
R58
4
74HC1G125
P1_RV[7..0] 4
P1_RV0
P1_RV1
P1_RV2
P1_RV3
P1_RV4
P1_RV5
P1_RV6
P1_RV7
P1_GY0
P1_GY1
P1_GY2
P1_GY3
P1_GY4
P1_GY5
P1_GY6
P1_GY7
P1_GY[7..0] 4
P1_BU[7..0] 4
P1_BU0
P1_BU1
P1_BU2
P1_BU3
P1_BU4
P1_BU5
P1_BU6
P1_BU7
C35502137-875
47
P1_CLK 4
47
47
P1_HSYNC 40.1uF
ADSOGOUT 4 02237-C05
P1_VSYNC 4
SOG_OUT
66
65
64
R171
2K
3
HSOUT
SOGOUT
VSOUT
GND1
GND2
GND3
GND4
GND5
GND6
GND7
GND8
GND9
GND10
2K
3
D13
DATACK
REFBYP
MIDSCV
R179
D25
3
VVCC
HSYNC
VSYNC
1
10
20
21
24
25
28
32
36
40
2
BAV99L
VVCC
R177
SOGIN
BAIN
BLUE0
BLUE1
BLUE2
BLUE3
BLUE4
BLUE5
BLUE6
BLUE7
0.1uF
1
1
D12
BAV99L
2
02037-CA8
3
VVCC
AD9883A_140
1
AVDDV
AVDDV
2
AVDDV
U10
GAIN
43
GND
BAV99L
RAIN
48
VBIN
R170
C339
VSYNC
DSUB_DETECT 5
GND
CLAMP
COAST
54
VGIN
VSOGIN
L21
VBLUE
GREEN0
GREEN1
GREEN2
GREEN3
GREEN4
GREEN5
GREEN6
GREEN7
VRIN
1nF
C165
02237-C04
47nF C179
SOGIN
L22
VSDA
SDA
SCL
A0
38
29
47nF C152
02237-268
47nF C161
FB_30_OHM_500MA
L0805
02337-536
VRED
RED0
RED1
RED2
RED3
RED4
RED5
RED6
RED7
FILT
57
56
55
4 AD_CLAMP
4 AD_COAST
CON1
D-SUB
VFLT1
R100
3.3K
02137-8AR
24C02
02037-0D6
SOP8
PVD1
PVD2
PVD3
PVD4
C202
3.9nF
02237-2JD
11
22
23
69
78
79
EVCK
C313
0.1uF
02237-C05
VDD1
VDD2
VDD3
VDD4
VDD5
VDD6
7
GND11
GND12
GND13
GND14
GND15
GND16
GND17
GND18
GND19
GND20
A
A
ZD3
5.6V/NC
2
1
D9
BAV70L
SOT23-132
4
02037-294
LL34
VCLK
PVDDV
V33
41
44
47
50
53
60
61
63
68
80
SCL
SDA
WP
AVDDV
C201
39nF
02237-2JE
39
42
45
46
51
52
59
62
8
VCC
6
5
3
3
5 EDID_WP
C
C
4K7
+5V_STBY_PWR
U36
GND
R84
4K7
VVCC
4K7
AVD3
AVD4
AVD5
AVD6
AVD7
AVD8
AVD9
AVD10
R82
R83
47
DDP2000 FLASH
P3P3V_STBY
Layout Supports 4, 8, 16Mb FLASH
C195
0.1U
02237-C05
C217
0.1U
02237-C05
C305
0.1U
02237-C05
C307
0.1U
02237-C05
P3P3V_STBY
U29B
PMADR_[20..0]
VCC
37
U14
PMDAT_15
PMDAT_14
PMDAT_13
PMDAT_12
PMDAT_11
PMDAT_10
PMDAT_9
PMDAT_8
PMDAT_7
PMDAT_6
PMDAT_5
PMDAT_4
PMDAT_3
PMDAT_2
PMDAT_1
PMDAT_0
45
43
41
39
36
34
32
30
44
42
40
38
35
33
31
29
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
A13
A14
A15
A16
A17
A18
A19
DQ15/A-1
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
P3P3V_STBY
/CE
/WE
/OE
PMADR_1
PMADR_2
PMADR_3
PMADR_4
PMADR_5
PMADR_6
PMADR_7
PMADR_8
PMADR_9
PMADR_10
PMADR_11
PMADR_12
PMADR_13
PMADR_14
PMADR_15
PMADR_16
PMADR_17
PMADR_18
PMADR_19
PMADR_20
26
28
11
PM_CS1
PM_OE
PM_WE
/BUSY
R112
R109
10K
R108
0
R107
10K
R106
10K
02137-8H7
02137-8J8
02137-8H7
02137-8H7
/BYTE
46
VSS
/RESET
PM_WE
PM_OE
P3P3V_STBY
10K
47
12
02137-8H7
PUM_ARSTZ
R90
33
33 02137-8RF
02137-8RF
R89
PM_CS3
33
02137-8RF
R92
PM_CS1
33
02137-8RF
R91
AM29LV160DB-90EI 02034-0016-01
7
VDD
VDD
VDD
9
RD_RQ[7..0]
RD_RQ7
RD_RQ6
RD_RQ5
RD_RQ4
RD_RQ3
RD_RQ2
RD_RQ1
RD_RQ0
R1
T1
T3
U1
U3
V1
V3
W1
RD_DQB[7..0]
33
02137-8RF R86
02137-8RF R87
33
33
SDRAM_CAS
SDRAM_RAS
PMDAT_0
PMDAT_1
PMDAT_2
PMDAT_3
PMDAT_4
PMDAT_5
PMDAT_6
PMDAT_7
PMDAT_8
PMDAT_9
PMDAT_10
PMDAT_11
PMDAT_12
PMDAT_13
PMDAT_14
PMDAT_15
J29
K26
K27
K28
K29
K30
L27
L28
L29
L30
M26
M27
M28
M29
M30
N27
H26
G30
F29
G27
SR_DQMHG29
SR_DQML G28
N29
N28
PMDAT_0
PMDAT_1
PMDAT_2
PMDAT_3
PMDAT_4
PMDAT_5
PMDAT_6
PMDAT_7
PMDAT_8
PMDAT_9
PMDAT_10
PMDAT_11
PMDAT_12
PMDAT_13
PMDAT_14
PMDAT_15
RD_SCK
RD_CMD
RD_SIO
RD_CFM
RD_CFMN
RD_CTM
RD_CTMN
9
SDRAM_DQM1
SDRAM_DQM0
PMBLS1
PMBLS2
RD_SCK
RD_CMD
RD_SIO
N3
N1
CFM
CFMN
P2
P3
CTM
CTMN
VDDIO1
VDDIO2
VDDIO3
VDDR1
VDDR2
VDDR3
VDDR4
VDDR5
VDDR6
VDDR7
VDDR8
VDDR9
VDDA2
VDDA3
CFM 9
CFMN 9
CTM 8,9
CTMN 8,9
R5
N5
VREF_ASIC
M5
T5
Y5
VDDIO
2.2uH 02337-449
U5
L5
J5
K5
V5
W5
AA5
AB5
AC5
C79 C82 C86
C254
C244
100U
02237-54C
0.1U
02237-C05
02237-C05 02237-C05
02237-C05
R3
P5
C69
C81
68P
68P
02237-264 02237-264
P1P5V_STBY
C83 C78 C76 C77 C84 C85 C87 C88 C89
C159
100U
0.1U
DDP2000
6
12
46
52
VTERM
L14
P1P5V_STBY
PJ402D-2
RD_SCK 9
RD_CMD 9
RD_SIO 9
VREF_ASIC
RD_VREF1
RD_VREF0
SDRAM_CLK
SDRAM_CKE
SDRAM_CAS
SDRAM_RAS
AE2
AE3
AE4
0.1U
1Mx16x4
CS3
CS2
CS1
CS0
RD_RQ7
RD_RQ6
RD_RQ5
RD_RQ4
RD_RQ3
RD_RQ2
RD_RQ1
RD_RQ0
9
0.1U
VSSQ
VSSQ
VSSQ
VSSQ
H29
H30
J27
J28
PMWE
PMOE
RD_DQA[7..0]
0.1U
VSS
VSS
VSS
RD_RQ[7..0]
DDP2000
H28
H27
0.1U
28
41
54
RD_DQB[7..0]
0.1U
49
02137-8RF R88
SDRAM_CLK
SDRAM_CKE
PMDAT_[15..0]
RD_DQB7
RD_DQB6
RD_DQB5
RD_DQB4
RD_DQB3
RD_DQB2
RD_DQB1
RD_DQB0
0.1U
37
38
19
18
17
16
39
15
AC3
AC1
AB3
AB1
AA3
AA1
Y3
Y1
W3
0.1U
CKE
CLK
CS
RAS
CAS
WE
UDQM
LDQM
SDRAM_CKE
SDRAM_CLK
PM_CS3
SDRAM_RAS
SDRAM_CAS
PM_WE
SR_DQMH
SR_DQML
RD_DQA7
RD_DQA6
RD_DQA5
RD_DQA4
RD_DQA3
RD_DQA2
RD_DQA1
RD_DQA0
0.1U
NC/RFU
02037-G79
PMADR_14
PMADR_13
PMADR_12
PMADR_11
PMADR_10
PMADR_9
PMADR_8
PMADR_7
PMADR_6
PMADR_5
PMADR_4
PMADR_3
PMADR_2
PMADR_1
PMADR_0
RD_DQB8
RD_DQB7
RD_DQB6
RD_DQB5
RD_DQB4
RD_DQB3
RD_DQB2
RD_DQB1
RD_DQB0
RD_DQA[7..0]
H3
H1
J3
J1
K3
K1
L3
L1
M3
0.1U
40
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
21
20
36
35
22
34
33
32
31
30
29
26
25
24
23
RD_DQA8
RD_DQA7
RD_DQA6
RD_DQA5
RD_DQA4
RD_DQA3
RD_DQA2
RD_DQA1
RD_DQA0
0.1U
2
4
5
7
8
10
11
13
42
44
45
47
48
50
51
53
BA1
BA0
NC
A11
A10/AP
A9
A8
TSOP54-08M
A7
A6
A5
A4
A3
A2
A1
A0
PMADR_00
PMADR_01
PMADR_02
PMADR_03
PMADR_04
PMADR_05
PMADR_06
PMADR_07
PMADR_08
PMADR_09
PMADR_10
PMADR_11
PMADR_12
PMADR_13
PMADR_14
PMADR_15
PMADR_16
PMADR_17
PMADR_18
PMADR_19
PMADR_20
0.1U
PMDAT_0
PMDAT_1
PMDAT_2
PMDAT_3
PMDAT_4
PMDAT_5
PMDAT_6
PMDAT_7
PMDAT_8
PMDAT_9
PMDAT_10
PMDAT_11
PMDAT_12
PMDAT_13
PMDAT_14
PMDAT_15
VDDQ
VDDQ
VDDQ
VDDQ
1
14
27
3
9
43
49
P3P3V_STBY
U37
P27
P28
P29
P30
R27
R28
R29
R30
T30
T29
T28
T27
U30
U29
U28
U27
V29
V28
V27
W30
W29
PUM_ARSTZ 5
VSS
15
NC
NC
NC
27
10
13
14
25
24
23
22
21
20
19
18
8
7
6
5
4
3
2
1
48
17
16
9
PMADR_0
PMADR_1
PMADR_2
PMADR_3
PMADR_4
PMADR_5
PMADR_6
PMADR_7
PMADR_8
PMADR_9
PMADR_10
PMADR_11
PMADR_12
PMADR_13
PMADR_14
PMADR_15
PMADR_16
PMADR_17
PMADR_18
PMADR_19
PMADR_20
02237-54C
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
DDP2000 DATA
U29A
02137-932
22,1/16W,5%
9
10
11
12
13
14
15
16
2 P1_BU[7..0]
P1_BU7
P1_BU6
P1_BU5
P1_BU4
P1_BU3
P1_BU2
P1_BU1
P1_BU0
D10
E10
B9
C9
D9
A8
B8
C8
P1_GY7
P1_GY6
P1_GY5
P1_GY4
P1_GY3
P1_GY2
P1_GY1
P1_GY0
E12
A11
B11
C11
D11
A10
B10
C10
P1_RV7
P1_RV6
P1_RV5
P1_RV4
P1_RV3
P1_RV2
P1_RV1
P1_RV0
D14
B13
C13
D13
A12
B12
C12
D12
PORT1_A_7
PORT1_A_6
PORT1_A_5
PORT1_A_4
PORT1_A_3
PORT1_A_2
PORT1_A_1
PORT1_A_0
2 P1_GY[7..0]
PORT1_B_7
PORT1_B_6
PORT1_B_5
PORT1_B_4
PORT1_B_3
PORT1_B_2
PORT1_B_1
PORT1_B_0
DDP2000
2 P1_RV[7..0]
TP16
TP15
TP6
TP17
P1_VSYNC
P1_HSYNC
P1_ACTDATA
P1_CLK
2 P1_VSYNC
2 P1_HSYNC
2
P1_CLK
2 AD_COAST
2 AD_CLAMP
2 ALF_VSYNC
2 ALF_HSYNC
2 ADSOGOUT
17 P2_Y[7..0]
17 P2_UV[7..0]
ALF_VSYNC
ALF_HSYNC
SOG
E1
F4
F3
F2
F1
G4
G3
G2
P2_UV7
P2_UV6
P2_UV5
P2_UV4
P2_UV3
P2_UV2
P2_UV1
P2_UV0
C2
C1
D3
D2
D1
E4
E3
E2
P2_Y[7..0]
P2_UV[7..0]
P2_FIELD
P2_VSYNC
P2_HSYNC
P2_ACTDATA
P2_CLK
B15
D15
A14
B14
C14
P2_Y7
P2_Y6
P2_Y5
P2_Y4
P2_Y3
P2_Y2
P2_Y1
P2_Y0
TP10TP11
TP10
TP11TP7 TP12
17 P2_FIELD
17 P2_VSYNC
17 P2_HSYNC
17 P2_ACTDATA
17
P2_CLK
D8
E8
A7
B7
C7
B5
C5
D5
A4
B4
C4
A3
B3
B6
C6
D6
A5
D7
PORT1_C_7
PORT1_C_6
PORT1_C_5
PORT1_C_4
PORT1_C_3
PORT1_C_2
PORT1_C_1
PORT1_C_0
PORT1_FLD
PORT1_VSYNC
PORT1_HSYNC
PORT1_ACTDATA
PORT1_CLK
COAST
CLAMP
ALF_VSYNC
ALF_HSYNC
SOG
PORT2_A_7
PORT2_A_6
PORT2_A_5
PORT2_A_4
PORT2_A_3
PORT2_A_2
PORT2_A_1
PORT2_A_0
PORT2_B_7
PORT2_B_6
PORT2_B_5
PORT2_B_4
PORT2_B_3
PORT2_B_2
PORT2_B_1
PORT2_B_0
PORT2_C_7
PORT2_C_6
PORT2_C_5
PORT2_C_4
PORT2_C_3
PORT2_C_2
PORT2_C_1
PORT2_C_0
DD63
DD62
DD61
DD60
DD59
DD58
DD57
DD56
DD55
DD54
DD53
DD52
DD51
DD50
DD49
DD48
DD47
DD46
DD45
DD44
DD43
DD42
DD41
DD40
DD39
DD38
DD37
DD36
DD35
DD34
DD33
DD32
DD31
DD30
DD29
DD28
DD27
DD26
DD25
DD24
DD23
DD22
DD21
DD20
DD19
DD18
DD17
DD16
DD15
DD14
DD13
DD12
DD11
DD10
DD9
DD8
DD7
DD6
DD5
DD4
DD3
DD2
DD1
DD0
SACBUS
SACCLK
DCLK
LOADB_Z
SCTRL
TRC
PORT2_FLD
PORT2_VSYNC
PORT2_HSYNC
PORT2_ACTDATA
PORT2_CLK
DMDSERIN
AJ12
AK12
AG13
AH13
AJ13
AG14
AH14
AJ14
AK14
AG15
AH15
AJ15
AK15
AK16
AJ16
AH16
AG16
AK17
AJ17
AH17
AG17
AJ18
AH18
AG18
AK19
AJ19
AH19
AG19
AF19
AK20
AJ20
AH20
AG20
AK21
AJ21
AH21
AG21
AJ22
AH22
AG22
AK23
AJ23
AH23
AG23
AK24
AJ24
AH24
AG24
AJ25
AH25
AG25
AK26
AJ26
AH26
AG26
AK27
AJ27
AH27
AK28
AG28
AG29
AG30
AF27
AF28
50
02137-932
22,1/16W,5%
8
7
6
5
4
3
2
1
02137-932
22,1/16W,5%
8
7
6
5
4
3
2
1
02137-932
22,1/16W,5%
8
7
6
5
4
3
2
1
02137-932
22,1/16W,5%
8
7
6
5
4
3
2
1
DCLK_L1
LOADB_LZ1
SCTRL_L1 R77
TRC_L1
R75
R160
PR6
02137-932
22,1/16W,5%
9
10
11
12
13
14
15
16
8
7
6
5
4
3
2
1
9
10
11
12
13
14
15
16
PR9
02137-932
22,1/16W,5%
9
10
11
12
13
14
15
16
8
7
6
5
4
3
2
1
9
10
11
12
13
14
15
16
PR12
02137-932
22,1/16W,5%
9
10
11
12
13
14
15
16
8
7
6
5
4
3
2
1
PR14
AE28
AE27
AF30
AF29
PJ402D-2
9
10
11
12
13
14
15
16
PR11
SACBUS1 R63
SACCLK1 R52
AF12
8
7
6
5
4
3
2
1
PR7
AG12
AH12
DDP2000
DD_63
DD_62
DD_61
DD_60
DD_59
DD_58
DD_57
DD_56
DD_55
DD_54
DD_53
DD_52
DD_51
DD_50
DD_49
DD_48
DD_47
DD_46
DD_45
DD_44
DD_43
DD_42
DD_41
DD_40
DD_39
DD_38
DD_37
DD_36
DD_35
DD_34
DD_33
DD_32
DD_31
DD_30
DD_29
DD_28
DD_27
DD_26
DD_25
DD_24
DD_23
DD_22
DD_21
DD_20
DD_19
DD_18
DD_17
DD_16
DD_15
DD_14
DD_13
DD_12
DD_11
DD_10
DD_9
DD_8
DD_7
DD_6
DD_5
DD_4
DD_3
DD_2
DD_1
DD_0
9
10
11
12
13
14
15
16
PR15
PR16
22
22 02137-8M0
02137-8M0
SACBUS
SACCLK
DD[63..0]
SACBUS 14
SACCLK 14
R72
R70
22
2202137-8M0
02137-8M0
22
02137-8M0
SCTRL
TRC
DMD_SERIN
14
DD63
DD62
DD61
DD60
DD59
DD58
DD57
DD56
DD55
DD54
DD53
DD52
DD51
DD50
DD49
DD48
DD47
DD46
DD45
DD44
DD43
DD42
DD41
DD40
DD39
DD38
DD37
DD36
DD35
DD34
DD33
DD32
DD31
DD30
DD29
DD28
DD27
DD26
DD25
DD24
DD23
DD22
DD21
DD20
DD19
DD18
DD17
DD16
DD15
DD14
DD13
DD12
DD11
DD10
DD9
DD8
DD7
DD6
DD5
DD4
DD3
DD2
DD1
DD0
SCTRL 14
TRC 14
DMD_SERIN 14
DCLK
LOADB_Z
22
2202137-8M0
02137-8M0
C353 C354
22pF
22pF
DCLK 14
LOADB_Z 14
DDP2000 MCU
CN2
15 KEYPD_PWR
15 KEYPD_MENU
P3P3V_STBY_PWR
P3P3V_STBY
C241
0.1U
R74
A0
A1
A2
VSS
VCC
WP
SCL
SDA
SP_R+
SP_R-
13
SP_RSP_L+
13
SP_L-
1
2
3
4
5
6
7
8
RP1
SP_L+
SP_LKEYPD_PWR
KEYPD_MENU
KEYPD_UP
KEYPD_DOWN
KEYPD_LEFT
KEYPD_RIGHT
R71
POWER_LED
LED_SYS2
LED_LAMP1
LED_LAMP2
15 POWER_LED
02237-C05
1K
1K
02137-8A0 02137-8A0
U18
1
2
3
4
SP_R+
13
4.7K 02158-0472-00
16
15
14
13
12
11
10
9
P3P3V_STBY
13
8
7
6
5
P3P3V_STBY_PWR
KEY_SOURCE
IR1
FM24C08UFL 02033-0010-00
KEY_AUTO
P3P3V_STBY
P3P3V_STBY
1
2
3
4
SCL0
SDA0
D
R93
3.3K,5%
02137-8H3
GND1
15,16
15,16
R94
1.5K,5%
2,13,16,17
02137-8F4
2,13,16,17
IR0
IR1
SDA0
SCL0
4
3
2
1
R96
R97
27
27
IR0
IR1
C27
C29
SDA0
SCL0
A27
B27
02137-8J4 B28
02137-8J4 A28
PWM0
PWM1
PWM2
PWM3
PWM0
PWM1
PWM2
PWM3
B24
A24
E23
D23
N1
10
10
10
10
IR0
IR1
PWRGOOD
EXT_ARST
EXT_ARSTZ
PUM_ARSTZ
SYSRSTZ
POSENSE
SDA0
SCL0
GPIO_31
NEC_PULSE
PULSE
D24
C30
A26
C25
D25
SSP1_CS0
SSP1_CLK
SSP1_DI
SSP1_DO
SSP1_CS0
SSP1_CLK
SSP1_DI
SSP1_DO
LOW VOLTAGE
11 SSP0_CS0
11 SSP0_CLK
OSRAM
PULSE
11 SSP0_DO
USHIO
LOW VOLTAGE
P3P3V
P3P3V
R18
560
R244
4.7k
02137-8J8
B25
E28
D26
B26
C26
SSP0_CS0
SSP0_CLK
SSP0_DI
SSP0_DO
UART1_RXD
UART1_TXD
UART1_CTS
UART1_RTS
UART1_RXD
UART1_TXD
UART1_CTS
UART1_RTS
R17
R20
D30
E27
D29
D28
0 02137-8J8
560 02137-8G6
POWER
0
0 02137-8J8
R277
C237
0.1U
02237-C05
SSP1_CS1
SSP1_CS0
SSP1_CLK
SSP1_DI
SSP1_DO
DDP2000
SSP0_CS1
SSP0_CS0
SSP0_CLK
SSP0_DI
SSP0_DO
UART1_RXD
UART1_TXD
UART1_CTS
UART1_RTS
1
02137-822
UART
Q16
B
2N3904
02011-0015-00
02137-8G6
R19
560
4
U22
2
74AHC1G125 02076-0014-00
51
C24
R69
3.3K,5%
02137-8H3
GPIO_23
GPIO_22
GPIO_21
GPIO_20
GPIO_19
GPIO_18
GPIO_17
GPIO_16
GPIO_15
GPIO_14
GPIO_13
GPIO_12
GPIO_11
GPIO_10
GPIO_9
GPIO_8
GPIO_7
GPIO_6
GPIO_5
GPIO_4
GPIO_3
GPIO_2
GPIO_1
GPIO_0
E21 GPIO_23
D21 GPIO_22
C21 GPIO_21
B21
A21
D20
C20
B20
A20
E19
D19
C19
B19
A19
D18
C18
B18
D17
C17
B17
A17
D16
C16
B16
P3P3V_STBY
R68
R67
0
0
FAN3_LOCKD
GPIO_19
R224 0
FAN2_LOCKD
GPIO_17
R65 0
FAN1_LOCKD
BINSEL1
BINSEL0
GPIO_13
R227 0
GPIO_11
R225 0
GPIO_10
R226 0
LED_SYS1 R269 NC
LED_SYS2
LED_LAMP1
LED_LAMP2
KEYPD_RIGHT
KEYPD_LEFT
KEYPD_DOWN
KEYPD_UP
KEYPD_MENU
KEYPD_PWR_ON
CW_TACH
CW_INDEX
A23
B23
1
2
3
4
8
7
6
5
02137-8J8
02137-8J8
EDID_WP 2
PWR_OFF_CMD
02137-8J8
USB_ENZ
FAN2_LOCKD 12
KEY_SOURCE
KEY_AUTO
KEYPD_PWR_ON
PJ402D-2
CWTACH 11,16
CWINDEX 11,16
TP20
R274
0
02137-8J8
R66
3.3K,5%
02137-8H3
FAN1_LOCKD 12
BINSEL1 14
BINSEL0 14
DSUB_DETECT 2
02137-8J8
02137-8J8
02137-8J8
P3P3V_STBY
FAN3_LOCKD 12
02137-8J8
CWTACH
CWINDEX
LMPSYNC
LMPSTAT
LMPCTRL
DDP1000_40
1K
EXT_ARSTZ 10,11,17
PUM_ARSTZ 3
SYSRSTZ 7
POSENSE 16
TP19
UART0_RXD
UART0_TXD
UART0_CTS
UART0_RTS
1
U49
74HC1G125 02076-0014-00
R282
2
4
R116
02137-8J8
D22
C22
0 02137-8J8
B22
C
Ballast Control
F27
F28
E30
E29
R85
SCI
UART
E
1
2
3
4
5
C352
0.1U
JTAG_SEL
PAL_DEBUG
FOR USHIO : R20/NC ; R277/OP
FLAG
GND
C351
0.1U
SW DIP-4
02137-8G6
J1
16 TH_SW_NO
16
16
16
16
C350
0.1U
EXT_ARSTZ
PUM_ARSTZ
SYSRSTZ
POSENSE
PWM0
PWM1
PWM2
PWM3
IGNITION TYPE BY SCI
NEC_NO PULSE
C349
0.1U
SW1
USBDATP
USBDATN
TP26TP27TP25TP24
BALLAST
AH8
AK5
AG6
AH6
AJ8
AK8
R48
3.3K,5%
02137-8H3
TP29TP23TP21TP22
2
2
N1
N2
1
12
12
12
ESD4
11
1608SGX
02037-D43
N2
1
KS-001-BNW(USB)
ESD3
1608SGX
02037-D43
R157
3.3K,5%
02137-8H3
U29D
15
2
5
GND2
02237-C05
02237-C05
02237-C05
02237-C05
NDS332P/SOT
R95
1.5K,5%/NC
02137-8F4
P3P3V_STBY
B2S
J4
1
6
P3P3V_STBY
4x1/1.5mm
USB_ENZ
28P/FPC
FORCCE PROG MODE
02437-68P
CLOSE TO DDP2000
BIMETAL SWITCH
S
JP1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
J2
Q1
G
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
DDP2000 POWER
P1P5V_STBY
P2P5V_STBY
P3P3V_STBY
TRACE OF 12mils
DDP2000 Decoupling for +3.3V
P3P3V_STBY
+ C108
C75
C74
C96
C114
C124
C140
C145
C163
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
AB26
AD5
AD26
AF13
AF14
AF17
AF18
AF22
AF24
E7
E9
E13
E14
E17
E18
E22
E24
G5
G26
J26
N26
P26
U26
V26
AF7
AG9
P3P3V_STBY
+ C164
10UF/6.3V
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
AJ28
AJ11
AJ10
AH30
AH29
AH10
AH9
AG11
AG10
AF23
AF21
AF1
AD2
AD1
C170
C171
C172
C173
C174
C175
C176
C105
0.1UF/16V/X7R
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1UF/16V/X7R
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
02237-C05
DDP2000 Decoupling for +2.5V
P2P5V_STBY
+ C110
100UF/10V
C128
C144
C150
C146
C177
C162
C178
C90
C113
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05
02237-54U
U18
V2
V4
V13
V14
V15
V16
V17
V18
V30
W2
W4
W12
W15
W16
W19
Y2
Y4
Y26
AA2
AA4
AB2
AB4
AB30
AC2
N30
P1
P4
P13
P14
P15
P16
P17
P18
R2
R4
R12
R13
R14
R15
R16
R17
R18
R19
R26
T2
T4
T12
T13
T14
T15
T16
T17
T18
T19
T26
U2
U4
U13
U14
U15
U16
U17
DDP2000
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
DDP2000
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
A1
A2
A6
A9
A13
A18
A22
A25
A29
A30
B1
B2
B29
B30
C3
C28
D4
D27
E5
E6
E11
E15
E16
E20
E25
E26
F5
F26
F30
H2
H4
J2
J4
J30
K2
K4
L2
L4
L26
M1
M2
M4
M12
M15
M16
M19
N2
N4
N13
N14
N15
N16
N17
N18
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P3P3V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
P1P5V
U29E
P2P5V
P2P5V
P2P5V
P2P5V
P2P5V
P2P5V
P2P5V
P2P5V
P2P5V
M13
M14
M17
M18
N12
N19
P12
P19
U12
U19
V12
V19
W13
W14
W17
W18
10UF/6.3V 0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
0.1UF/16V/X7R
52
PJ402D-2
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
AK30
AK29
AK25
AK22
AK18
AK13
AK9
AK6
AK2
AK1
AJ30
AJ29
AJ2
AJ1
AH28
AH3
AG27
AG4
AF26
AF25
AF20
AF16
AF15
AF11
AF6
AF5
AE30
AE26
AE5
AC4
P1P5V_STBY
+ C100
10UF/6.3V
C101
0.1U
02237-C05
C102
0.1U
02237-C05
C103
0.1U
02237-C05
C104
0.1U
02237-C05
C115
0.1U
02237-C05
C125
0.1U
02237-C05
C116
0.1U
02237-C05
P1P5V_STBY
+ C106
10UF/6.3V
C126
0.1U
02237-C05
C142
0.1U
02237-C05
C148
0.1U
02237-C05
C143
0.1U
02237-C05
C149
0.1U
02237-C05
C155
C156
0.1U
0.1U
02237-C05 02237-C05
C157
0.1U
02237-C05
C158
0.1U
02237-C05
DDP2000 PERIPHRAL
PAL_DEBUG 5,15
TP-1 TP-1 TP-1 TP-1 TP-1 TP-1 TP-1 TP-1
R260
R259
R257
R258
0/NC
0/NC
0/NC
0/NC
U29G
TRACEPKT[7..0]
02137-933
39,1/16W,5%
9
10
11
12
13
14
15
16
TRACEPKT7
TRACEPKT6
TRACEPKT5
TRACEPKT4
TRACEPKT3
TRACEPKT2
TRACEPKT1
TRACEPKT0
PR4
02137-933
39,1/16W,5%
9
10
11
12
13
14
15
16
PIPESTAT2
PIPESTAT1
PIPESTAT0
TRACESYNC
TRACECLK
RTCK
8
7
6
5
4
3
2
1
8
7
6
5
4
3
2
1
12N315
12N317
12N319
12N321
12N323
12N325
12N327
12N329
12N331
12N333
12N335
12N337
12N339
12N341
AB28
AB29
AA26
AA27
AA28
AA29
AA30
Y27
Y28
Y29
Y30
W26
W27
W28
TRACEPKT7
TRACEPKT6
TRACEPKT5
TRACEPKT4
TRACEPKT3
TRACEPKT2
TRACEPKT1
TRACEPKT0
TSTPT_7
TSTPT_6
TSTPT_5
TSTPT_4
TSTPT_3
TSTPT_2
TSTPT_1
TSTPT_0
PIPESTAT2
PIPESTAT1
PIPESTAT0
TMS1
TMS2
TRACESYNC
TRACECLK
RTCLK
TDI
TCK
TRTZ
ARM_WRAPMODE
SCAN_MODE
TEST_EN
ICTSENZ
BIST_EN
IDDTEST_MODE
12N337
12N339
12N341
DDP2000
PR3
P3P3V_STBY
P3P3V_STBY
R208
R184
10K
10K
02137-8H7
02137-8H7
U41
2
P3P3V_STBY
P3P3V:5 ; GND :3
R275
4
ICE_RSTZ
2
C346
0.1U/NC
02237-C05
JTAG_SEL
74LVC1G08DBV 02076-0015-00
P3P3V:5 ; GND :3
53
TDO1
TDO2
TDO1 17
AF4
AG1
TMS1
TMS2
TMS1 17
AG2
AG3
AH1
TDI
TCK
TRSTZ
C15
AB27
AH2
G1
AH11
AH7
TCK
17
JP4
TMS1
TDO1_OUT
17 TDO1_OUT
SYSRSTZ
TRSTZ
TDI
TMS2
TCK
RTCK
TRACEPKT[15..8]
TDO2
ICE_RSTZ
TRACEPKT15
TRACEPKT14
TRACEPKT13
TRACEPKT12
TRACEPKT11
TRACEPKT10
TRACEPKT9
TRACEPKT8
TRACEPKT7
TRACEPKT6
TRACEPKT5
TRACEPKT4
TRACEPKT3
TRACEPKT2
TRACEPKT1
TRACEPKT0
TRACECLK
TRACESYNC
P3P3V_STBY PIPESTAT0
PIPESTAT1
PIPESTAT2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
38
1
4
SYSRSTZ
AF3
AF2
TRACEPKT[15..8]
74LVC1G07DBV 02076-0010-00
U42
1K, 1%/NC
02137-8A0
TRACEPKT15
TRACEPKT14
TRACEPKT13
TRACEPKT12
TRACEPKT11
TRACEPKT10
TRACEPKT9
TRACEPKT8
PR5
TDO1
TDO2
12N331
12N333
12N335
8
7
02137-8J8 6
5
4
3
2
1
AJ3
AK3
AH4
AJ4
AK4
AG5
AH5
AJ5
37
12N315
12N317
12N319
12N321
12N323
12N325
12N327
12N329
02137-933
39,1/16W,5%
9
10
11
12
13
14
15
16
HIROSE FH12A-36S-0.5SH
TP3 TP5 TP4 TP9 TP8 TP14TP13TP18
PJ402D-2
ZIFF 36
DDP2000 PLL
VDRCG
U29C
VDRCG
DRCG_REFCLK
MLPF
DRCGPDZ
FEPLLVCCA
FEPLLGNDA
OCLKA
OCLKB
0 / NC
02137-8J8
R152
0
02137-8J8
AJ6
AG7
REFCLK
SCLKN
PCLKM
AE1
DRCGPDZ
H5
AG8
AK7
02137-8T8
R47
22,2% OCLKA
02137-8T8
R50
22,2% OCLKB
LITE_EN
OPTC_EN
15
14
OCLKA 11
R16
1K
02137-822
OCLKB 17
24
23
13
R5
1K
02137-822
DRCGPDZ
STOPZ
DDP2000
12
11
P3P3V_STBY
10
02137-8J8
S0
S1
S2
16
22
C249
CDCR83
CLOSE TO DDP2000
P1P5V_STBY
P3P3V_STBY
VDDIR
NC
VDDIPD
C18
0.1U
02237-C05
MI0603J680R
02337-F00
L8
C246
C131
0.1U
02237-C05
FEPLLGNDA
MI0603J680R
02337-F00
0.1U
02237-C05
MI0603J680R
02337-F00
C35
+
33uF/6.3V
C24
C25
C27
C26
C14
C15
C17
C16
0.1U
68P
0.1U
68P
0.1U
68P
0.1U
68P
CTMN 3,9
02237-C05
02237-C05
02237-C05
02237-C05
02237-547
02237-264
02237-264
02237-264
02237-264
CDCR83(DRCG)3.3V DECOUPLING CAPS
CDCR83(DRCG)3.3V DECOUPLING CAPS
P3P3V_STBY
R35
L6
MI0603J680R
02337-F00
MAVD
C58
MI0603J680R
02337-F00
C111
0.1U
02237-C05
L5
C109
0.1U
02237-C05
MAVS
0.1U
02237-C05
MI0603J680R
02337-F00
54
PJ402D-2
U25
Y2
L2
P2P5V_STBY
1K
02137-822
C59
0.1U
02237-C05
1
4
EN
VCC
50MHZ
R268
OUT
GND
3
2
2
0
CLK_REF
4
C337
74LVC1G04DBV
56.2,1%
CLKTM
C56
0.1U
02237-C05
R34
19
VDRCG
FEPLLVCCA
3,9
56.2,1%
R123 110,1%
02137-8C5
CTMN1_M
CTMN
02137-8FC
18
L15
L12
C130
0.1U
02237-C05
10PF/NC
02237-253
PWRDNB
STOPB
DDP2000
C13
0.1U
02237-C05
CTM
CTM
R33 02137-8C5
U17
CLKB
0 / NC
R124 110,1%
CTM1_M
02137-8FC
20
MULT0
MULT1
P2P5V_STBY
1
R51
REFCLK
SYNCLKN
PCLKM
CLK
VDRCG
P2P5V_STBY
MOSC0
MOSC0_N
AJ7
AF8
2
7
6
GNDO
GNDO
CLK_REF
R231
1K
1K
02137-822 02137-822
VDDO
VDDO
MDVD
MDVS
R14
17
21
AF9
AF10
C91
0.1U
AJ9
02237-C05
FEPLLVCCA A16
FEPLLGNDA A15
AD3
AD4
R15
9
3
DRCG_SCLKN
DRCG_PCLKM
02137-8T8
R37
22,2% SCLKN
8N286 02137-8T8
8N284 R36
22,2% PCLKM
02137-8T8
R38
22,2% REFCLK
VDDC
VDDP
MAVD
MAVS
GNDP
GNDI
GNDC
AK11
AK10
4
5
8
MAVD
MAVS
P1P5V_STBY
10PF/NC
02237-253
DDP2000 RAMBUS
VTERM
1
2
3
4
5
6
7
8
VTERM
02137-933
39,2%
RP3
1
2
3
4
5
6
7
8
P2P5V_STBY P2P5V_STBY
R6
39,2%
R7
39,2%
02137-8CF
02137-8CF
C20 3
CFMN
0.1U
02237-C05
CFM
3,8
3,8
CTM
CTMN
A5
A3
CTM
CTMN
CFM
E1
D1
C7
D7
CFMN
VREF_RDRAM
D2
CFMN
C34
0.1U
02237-C05
CMD
SCK
CTM
CTMN
CFM
CFMN
16
15
14
13
12
11
10
9
A2
J2
G5
H5
F3
VCMOS
VCMOS
VDD
VDD
VDD
DQA0
DQA1
DQA2
DQA3
DQA4
DQA5
DQA6
DQA7
DQA8
02037-G65
3
RD_DQA[7..0]
3
RD_DQB6
RD_DQB5
RD_DQB4
RD_DQB3
RD_DQB2
RD_DQB1
RD_DQB0
RD_DQA[7..0]
RD_DQA0
C1
C2
C6
B1
B7
B6
B2
A7
A1
RD_DQA1
RD_DQA2
RD_DQA3
RD_DQA4
RD_DQA5
RD_DQA6
RD_DQA7
RD_RQ7
CFM
RD_CMD
RD_SCK
U20
SIO1
SIO0 K4R271669D-TCS8
RD_DQB[7..0]
RD_DQB7
VREF
P2P5V_STBY
16
15
14
13
12
11
10
9
3
3 RD_CMD
3 RD_SCK
J3
J5
RD_DQB[7..0]
J1
J7
H2
H6
H7
H1
G2
G6
G7
GND
GND
GND
GND
GND
3 RD_SIO
1K, 1%
02137-8A0
RD_SIO
DQB8
DQB7
DQB6
DQB5
DQB4
DQB3
DQB2
DQB1
DQB0
RD_RQ2
E3
F5
G3
H3
J6
R26
RQ0
RQ1
RQ2
RQ3
RQ4
RQ5
RQ6
RQ7
GND
GND
GND
GND
GNDa
G1
F2
F6
F7
F1
E7
E6
E2
A6
B3
C5
D3
D5
RD_RQ0
RD_RQ1
RD_RQ2
RD_RQ3
RD_RQ4
RD_RQ5
RD_RQ6
RD_RQ7
VDD
VDD
VDD
VDDa
B5
C3
E5
D6
RD_DQB2
RD_RQ[7..0]
5
3 RD_RQ[7..0]
RD_DQA2
16
15
14
13
12
11
10
9
02137-933
39,2%
RP2
RP4
39,2%
02137-933
+
1
2
3
4
5
6
7
8
C38
150UF/6.3V
02237-533
Layout Compatible with 128Mb or
144Mb Consumer RDRAM
VTERM
TP2
TP1
P2P5V_STBY
VREF_RDRAM
SC1565IST- 1.8TR
VREF_ASIC
VREF_RDRAM
U4
1
C245
0.1U
02237-C05
+ C234
+ C19
4
10uF/16V
02237-512
2
+ C243
R39
3
100UF/6.3V
100UF/6.3V
C220
C219
C231
0.1U
0.1U
0.1U
02237-C05 02237-C05 02237-C05
R21
34,1%
02137-8C8
110,1% VREF_ASIC
R25
118,1%
C52
C57
0.1U
0.1U
02237-C05 02237-C05
C80
0.1U
02237-C05
02137-8BX
02237-54C
02037-AAF
02237-54C
VTERM BULK
DECOUPLING CAPS
VTERM
VTERM DECOUPLING CAPS
C230
C229
C228
C227
C226
C225
C224
C223
C222
C221
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
0.1U
02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05 02237-C05
55
PJ402D-2
C32
0.1U
02237-C05
C33
0.1U
02237-C05
C39
0.1U
02237-C05
C40
0.1U
02237-C05
DAD1000
SR16STROBE
SR16MODE1
SR16MODE0
SR16SEL1
SR16SEL0
15
2
3
4
5
SR16ADDR3
SR16ADDR2
SR16ADDR1
SR16ADDR0
16
17
18
19
+5V
R76
1K
5,11,17 EXT_ARSTZ
R73
10K/NC
02137-8F3
EXT_ARSTZ
SR16OEZ
C344
0.1U/NC
02237-C05
U29F
SR16SEL_1
SR16SEL_0
SR16ADDR_3
SR16ADDR_2
SR16ADDR_1
SR16ADDR_0
SR16OEZ
DDP2000
+12V
AC27
SR16STROBE
AE29
AD27
SR16MODE1
SR16MODE0
AC29
AC30
SR16SEL1
SR16SEL0
50
48
11
C188
+
C185
0.1U
10uF/16V
02237-C05 02237-512
80
71
70
61
40
31
30
21
VBIAS
following order: 40,31,30,21,80,71,70,61
AD28
AD29
AD30
AC26
AC28
SR16ADDR3
SR16ADDR2
SR16ADDR1
SR16ADDR0
SR16OEZ
C314
R180
0,5%
02137-721
C290
0.1U
VBIAS1
C291
+
02237-C05 02237-C05
A3
A2
A1
A0
DEV_ID1
DEV_ID0
/IRQZ
/RESETZ
/OEZ
VOFF_RAIL7
VOFF_RAIL6
VOFF_RAIL5
VOFF_RAIL4
VOFF_RAIL3
VOFF_RAIL2
VOFF_RAIL1
VOFF_RAIL0
VOFF
VCC
V12_SWL1
V12_SWL0
V12_3
V12_2
V12_1
V5REG
VRST_RAIL7
VRST_RAIL6
VRST_RAIL5
VRST_RAIL4
VRST_RAIL3
VRST_RAIL2
VRST_RAIL1
VRST_RAIL0
VBIAS_RAIL7
VBIAS_RAIL6
VBIAS_RAIL5
VBIAS_RAIL4
VBIAS_RAIL3
VBIAS_RAIL2
VBIAS_RAIL1
VBIAS_RAIL0
VBIAS
VRST
VBIAS_SWL 8
VBIAS_SWL
10uF/16V
02237-512
56
PJ402D-2
GND
GND
GND
GND
GND
GND
GND
GND
GND
VBIAS_LHI
46
53
55
60
C317
1
7
14
20
41
+
MBRST15
MBRST14
MBRST13
MBRST12
MBRST11
MBRST10
MBRST9
MBRST8
MBRST7
MBRST6
MBRST5
MBRST4
MBRST3
MBRST2
MBRST1
MBRST0
P3P3V
02137-8F3
R99
1K
IRQZ
43
78
73
68
63
38
33
28
23
49
VCC2
VCC2
VCC2A
ZD2
BZD27C8V2P
C302
C301
0.1U
0.1U
R183
0,5% VCC2
02137-721
C294
C293
+ C300
3.3UF/35V
02237-550
02237-C05 02237-C05
following order: 23,28,33,38,63,68,73,78
V5REG
47
0.1U
VRST
following order: 36,35,26,25,76,75,66,65
R192
VRST1
0,5%
13
02137-721
D14
12
VRST_SWL
C316
3.3UF/35V
02237-550
L24
SDT0402T-220M-S
02337-E87
0.1U
02237-C05
02237-C05
+ C200
1UF/16V
C306
02237-510
0.1U
02237-C05
76
75
66
65
36
35
26
25
STPS0560Z
02037-C88
VRST_SWL
L20
SDT0402T-220M-S
02337-E87
VBIAS_LHI 10
79
77
74
72
69
67
64
62
39
37
34
32
29
27
24
22
MBRST[15..0]
VCC2
D8
STPS0560Z
02037-C88
0.1U
3.3UF/35V
02237-550
9
STROBE
MODE1
MODE0
SEL1
SEL0
C
SR16MODE_1
SR16MODE_0
IRQZ
52
51
A
SR16STRB
C23
59
6
54
TP28
DAD_INT
45
44
OUT15
OUT14
OUT13
OUT12
OUT11
OUT10
OUT09
OUT08
OUT07
OUT06
OUT05
OUT04
OUT03
OUT02
OUT01
OUT00
C
P3P3V
SCPCK
SCPDI
SCPDO
SCPENZ
C
56
57
42
58
A
SSP1_CLK
SSP1_DO
SSP1_DI
SSP1_CS0
SSP1_CLK
SSP1_DO
SSP1_DI
SSP1_CS0
DAD1000 02037-ABG
A
U11
+
5
5
5
5
MBRST[15..0]
R105
1K
02137-8F3
P3P3V
C295
0.1U
02237-C05
C315
0.1U
02237-C05
14
MOTOR CONTROL
+5V
+12V
F2
PBY201209T-600Y-S
C248
0.1UF/16V/X7R
02337-F05
R245
R11 R3
R1
62K,5%
1K,5%/NC
02137-8F3
1K,5%/NC
1K,5%/NC
1K,5%/NC
8
15
0
OCLKA
CKMTR
EXT_ARSTZ
SSP0_CS0
SSP0_CLK
SSP0_DO
5,10,17 EXT_ARSTZ
5 SSP0_CS0
5 SSP0_CLK
5 SSP0_DO
1
16
20
21
22
23
BRAKEZ
OUTA
OSC
RESETZ
CSZ
CLOCK
DATAIN
OUTB
R12
0
R0603
02137-8J8
5
OUTA
0,5%
8
9
OUTB
OUTC
57
2
1
2
1
2
R129
R127
0,5%
D4
D3
D2
3
3
3
BAT54SW BAT54SW BAT54SW BAT54SW
02037-C65 02037-C65 02037-C65 02037-C65
3
2
CWY3
CWCTR
1
10
R119
17
CWTACH
R120
C10
CWTACH 5,16
R121
C9
C7
150,5%
150,5%
MOLEX 52207-0490
02437-GBT
CW MOTOR CONTROL
0.001UF/50V/X7R
0.001UF/50V/X7R
0.001UF/50V/X7R
C8
02137-7CT 02137-7CT
0.01UF/50V/X7R/NC
02237-204 02237-204 02237-204
02137-7CT
A round line is cut of
ground plane and no
power plane below here.
R13
10K
02137-8H7
PWM3 5
PJ402D-2
J8
4
CWY2
0,5%
02137-721
SECDAT
FILTER
D1
3
150,5%
-Include
Guard Ring Around
these components on top and
bottom layers
1
02137-721
These ground via need to separated .
C22
0.1U
02237-C05
R122
0,5%/NC
02137-721
R130
0,5%/NC
02137-721
02137-721
CWY1
GND
02237-510
02237-2J5
02237-2BQ
13
A8904CLB
19
14
U5
CST
GND
C64
1UF/16V
CRES
GND
4
DATAOUT
18
CST
02237-2BQ 02237-2BD
SEE MOTOR TIMING CAP.
CHART
12
CNTRTAP
7
0.22UF/25V/X7R
C66
CRES
CD2
CWD
CD1
GND
2700PF/10V/NP0
C21
2
3
24
6
4700PF/10V/NP0
C63
CD2
CWD
CD1
MFILT
2700PF/10V/NP0
OUTC
C62
2
Not Installed
R128
11
R126
OCLKA
ALVBB
R2
1
C236
0.1U
02237-C05
VBB
C235
0.1U
02237-C05
ALVDD
U14 Decoupling for +5V
+5V
F1
PBY160808T-121Y-S
+
C48
C255
R132
0.1U
10UF/16V
02237-C05
1K
VDD
C30
0.1U
02237-C05
02237-261
SEE MOTOR TIMING
CAP CHART
FAN CONTROL
Q5
02437-68D
E
0
02137-8J8
D7
G
33uH
02337-470
1K, 1%
R159
10K02137-8A0
02137-8H7
B220
C51
47uF/25V
P2N2907A
Q8
D
R243
33,5%
02137-8J0
D20
3x1_1.50mm_PTH(r)
02437-6CM
02137-8A0
R238
33,5%
02137-8J0
L28
FAN3_PWM
FDV301N
R236
G
Q11
B
C
C
1
2
3
PWM0 5
B220
A
E
3
R158
Q6
B
2
02137-8J8
1
2
3
R237
1K, 1%
PWM2 5
S
47uF/25V
C
C107
R242
33,5%
02137-8J0
A
FAN1_LOCKD 5
3x1_1.50mm_PTH
0
CN3
FDV301N
R173
33,5%
02137-8J0
33uH
02337-470
P2N2222A
5 FAN3_LOCKD
Q4
S
R228
R229
D
2
02137-8A0
FAN1_PWM
1
2
3
D21
IRFP9140/TO
1
R30
3.3K
02137-8H3
R174
33,5%
02137-8J0
L16
CN5
1
2
3
R164
33,5%
02137-8J0
B
R163
1K, 1%
E
E
3
P2N2222A
R49
3.3K
02137-8H3
Q9
P3P3V
B
D6
IRFP9140/TO
1
C
P3P3V
C
+15V
C
+15V
1K, 1%
R233
10K02137-8A0
02137-8H7
P2N2907A
+15V
L7
+15V
2
MI0603J680R
C
Q10
B
R250
3.3K
02137-8H3
02137-8A0
2
0
02137-8J8
D19
Q7
3x1_1.50mm_PTH(r)
02437-6CM
FDV301N
G
S
C
P2N2907A
R253
33,5%
02137-8J0
47uF/25V
R232 1K, 1%
10K 02137-8A0
02137-8H7
Q13
FDV301N
R249
B220
PWM1 5
A
E
A
Q12
B
C332
33,5%
02137-8J0
D23
R234
B220
R251
L31 33uH
02337-470
FAN4_PWM
Q15
B
P2N2907A
PWM2
G
S
47uF/25V 0
02137-8J8
1
2
3
E
R240
33,5%
02137-8J0
1
2
3
C
FAN2_LOCKD
5
C67
CN6
33,5%
02137-8J0
D
3x1_1.50mm_PTH(b)
02437-6CL
R230
R252
33,5%
02137-8J0
R241
33uH
02337-470
R248
1K, 1%
P2N2222A
02137-8A0
R246
FAN4_LOCKD
FAN2_PWM
C
1
2
3
Q14
B
C
L29
CN4
1
2
3
R239
33,5%
02137-8J0
2
3.3K
02137-8H3
D24
IRFP9140/TO
1
E
R235
1K, 1%
P2N2222A
3
C
R43
E
3
D22
IRFP9140/TO
1
P3P3V
D
1
P3P3V
R247 1K, 1%
10K 02137-8A0
02137-8H7
58
PJ402D-2
AUDIO
C296
330uF/PC6.3V
02237-084
R178 1K
U2
AINC_R
C242
C4
J7
0 R182
02137-8J8
1
4
AINC_R
C46
C41
0.47uF
02237-2A8
0.47uF
02237-2A8
0.47uF
02237-2A8
0.47uF
02237-2A8
17
18
9
3
11
AINC_L
2
15
23
2,5,16,17 SDA0
2,5,16,17 SCL0
2
N1
C44
1608SGX
02037-D43
2
N1
+5V
1608SGX
02037-D43
ROUT+
RLINEIN
ROUTRIN
PC-BEEP
0
R186
02137-8J8
0
R175
02137-8J8
4
10
16
0.47uF
7
02237-2A8
C43
0.47uF
6
02237-2A8
C42
0.47uF
5
02237-2A8
PVDD
PVDD
VDD
12
SP_R+
14
SP_R-
SDA
SCL
SHUTDOWN
A0
A1
I2CVDD
GND
GND
LHPIN
LOUT+
LLINEIN
LOUT-
+5V
SP_R- 5
FB2
47UH 02346-0029-00
C2
C45
C1
BYPASS
SP_R+ 5
8
19
20
SE/BTL
1
ESD2
N2
N2
ESD1
1
PHONOJACK STEREO-R
RHPIN
0.47uF
0.1U
02237-C05
21
02237-2FZ
22
+5V
+
0.1U
02237-C05
10uF/16V
02237-512
C251
+
+
C3
10uF/16V
02237-512
C247
10uF/16V
02237-512
13
1
2
SP_L+
24
SP_L-
SP_L+ 5
SP_L- 5
LIN
C303
TPA0172
330uF/PC6.3V
02237-084
R188
1K
TPA0127
I2C ADDRESS
WRITE D8H
READ
D9H
59
PJ402D-2
DMD CONNECTOR
P3P3V
J5
WR-120P-HF-HD-A1
L19
DMD_P3P3V_A
MI0603J680R
02337-F00
C289
VCC2
C287
+
VCC2
0.1U
02237-C05
33uF/6.3V
02237-547
4 DMD_SERIN
4
4
10 MBRST[15..0]
SACBUS
SACCLK
DMD_SERIN
SACBUS
SACCLK
MBRST[15..0]
MBRST7
MBRST6
MBRST5
MBRST4
MBRST3
MBRST2
MBRST1
MBRST0
DD1
DD2
DD3
DD4
DD5
DD6
DD7
DD8
DD17
DD18
DD19
DD20
DD21
DD22
DD23
DD24
DD33
DD34
DD35
DD36
DD37
DD38
DD39
DD40
DD49
DD50
DD51
DD52
DD53
DD54
DD55
DD56
4 DD[49:0]
1
3
5
7
9
11
13
15
17
19
21
23
25
27
29
31
33
35
37
39
41
43
45
47
49
51
53
55
57
59
61
63
65
67
69
71
73
75
77
79
81
83
85
87
89
91
93
95
97
99
101
103
105
107
109
111
113
115
117
119
2
4
6
8
10
12
14
16
18
20
22
24
26
28
30
32
34
36
38
40
42
44
46
48
50
52
54
56
58
60
62
64
66
68
70
72
74
76
78
80
82
84
86
88
90
92
94
96
98
100
102
104
106
108
110
112
114
116
118
120
BINSEL0
BINSEL1
BINSEL0 5
BINSEL1 5
DCLK
DCLK 4
LOADB_Z
LOADB_Z 4
TRC
SCTRL
TRC 4
SCTRL 4
MBRST[15..0]
MBRST15
MBRST14
MBRST13
MBRST12
MBRST11
MBRST10
MBRST9
MBRST8
60
PJ402D-2
10
DD57
DD58
DD59
DD60
DD61
DD62
DD63
DD0
DD9
DD10
DD11
DD12
DD13
DD14
DD15
DD16
DMD_P3P3V_B
P3P3V
L18
MI0603J680R
02337-F00
+ C286
DD25
DD26
DD27
DD28
DD29
DD30
DD31
DD32
33uF/6.3V
02237-547
DD41
DD42
DD43
DD44
DD45
DD46
DD47
DD48
DMD_P3P3V_B
DD[63..0]
DMD_P3P3V_B
C277
0.1U
02237-C05
FOR SVGA DMD
IF CONNECT TO SVGA DMD : DD0---> DD7
MBRST[15..0]
DD49--->DD56
DD[63..0]
4
POWER+PIC
C256
0.01U
02237-251
C330
C327
C55
C68
C
02346-0055-00
C94
D5
B220
RT
8
R135
100K
02137-814
GND
4
C239 C50
C238
+
+
0.1uF
0.1uF100uF/16V10uF/MC16V
S-C63MM
100uF/16V
S-C63MM
+ C65
P3P3V_STBY
+5V
D15
A
4
TAB
C266 C95
C265
+
+
0.1uF
1N4002
C
C214
C213
10uF
+ TANAD 0.1uF
P2P5V_STBY
U15
AIC1084-2.5
I
S-C63MM
VI<Part No.>
VO
TAB
O
4
C211
47uF/16V
+ S-C63MM
C212
0.1uF
47uF/25V 10uF/16V
02237-0A1 02237-512
5
SCP
100uF/16V
S-C63MM
TAB
A
R136
60.4k
02137-8P0
S-C63MM
U7
AIC1084-3.3
02037-0BY O
VI
VO
I
+
FB
7
P1P5V_STBY
L17 47uH
L17A
2
1
COMP
4
C252
C49
+
A
3
R145
30.1K
02137-8AP
590,1%
DTC
C
6
02137-8AP
+5V
PNP BEC
Q3
B
1
OUT
C328 C329 C331
+
+
GND
VCC
0.1uF
GND
R150
2
4
TAB
P3P3V
U23
AIC1117-3.3
02037-0BZ O
VI
VO
A
R151
499,1%
02137-8SC
R144 30.1K
I
C264
0.1U
02237-C05
E
C259
33p
02237-255
+5V
A
+
100uF/16V
S-C63MM
C260
3300P
02237-2BU
GND
I
GND
+12V
P3P3V_STBY_PWR
U44
AIC1084-3.3
02037-0BY O
VI
VO
A
+5V_STBY_PWR
02137-814
100K
R134
U24
TL5001A
P3P3V_STBY_PWR
+5V_STBY_PWR
C326
02237-280
22p/NC C54
R64
1K
+5V_STBY_PWR
FOR THERMAL SENSER
0.1uF
R271
J9
1
2
3
4
5
6
7
8
9
10
+5V_STBY_PWR
R147
STAND-BY PORT
+5V
3
Y1
JP5
+15V
+5V
+12V
+15V
STBY_CTRL
1
2
+12V
4.7K
2
20MHz/NC
02237-2805 KEYPD_MENU
C70
22p/NC
Header 1x2/1.5
3
R261 02137-8J8
0
5 POWER_LED
1
JST,PH,S10B-PH-SM3-TB
R281
1K
TH_SW_NO
4
TH_SW_NO
2
C
4
2
1
R264
0
R256
3K3
0.1uF
H1
H2
4MM
4MM
H3
H4
4MM
02137-8J8
02137-8J8
1
PIC_KEYPD_PWR
2
SN74AHC08PWR 02037-72M
PIC _ CONTROLLER
H5
4MM
4MM
H6
H7
4MM
H8
4MM
PJ402D-2
16
KEYPD_PWR 5
R270
4.7K
R276
14
KEYPD_PWR
U47A
U47A
+
R2IN
PWR_OFF_CMD 5
4.7K
7
R279
IR1 5,16
0
R266
4.7K
3
C334
0.1uF
+
02237-0AF
C333 100uF/16V
+
61
R255
4.7K/NC
+5V_STBY_PWR
C153
0.1uF
02237-0A2
C186 100uF/25V
+
4MM
8
P3P3V_STBY_PWR
close to connector
POWER MANAGER
9
C336
+15V
C160
0.1uF
+5V
C187 100uF/16V
+
10
0.1uF
C203
02346-0029-00
C250
C47
10uF/10V
0.1U
02237-C05 02237-512
11
74HC1G125 02076-0014-00
R265
+12V
02237-0A2
C215 100uF/25V
47uH
RS232
P3P3V_STBY_PWR
4.7K
4.7K
P5V_FILT
RA3
IR0 5,16
R218
0 02137-8J8
R220
0 02137-8J8
R254
KEYPD_PWR
0 02137-8J8
12
PWR_STBYON
02137-822
Second Thermal Sensor
Normal Close / YS11A140B-C6
2
IR1
R221
0 02137-8J8
2N3904
02011-0015-00
Header 1x2/1.5-NC
L1
RA4
14
13
U45
Q17
B
1K
1
IR0
E
JP6
+5V
GND
RA5
R272
U48
74HC1G125 02076-0014-00
R78
1
2
4
VDD
R262
0
5
RC5
POWER_KEY
02137-8J8
R267
6
RC4
POWEROFF
1K2
02153-0122-00
7
RC3
PW_CTR
0 R263
02137-8J8
PIC16F630
U43
5,7 PAL_DEBUG
+5V_STBY_PWR
HI : FULL DC CHANNEL OUT
LOW : STAND-BY MODE
1
1M/NC
KEYPD_PWR_ON
5
MISC
P5V_FILT
P3P3V
P3P3V
270
02137-8J1
C347
R278
C31
C11
0.01uF
02237-261
AIN0
AIN1
AIN3
SDA
SCL
AIN3/REF
MAX1037
SOT23-8
02054-0006-00
R115
R22
4
8.2K
5
Yout
C36
R28
6
1
3
7
Vref
Tout
GND
SCK
Xout
02137-8P5
0
02137-8J8
R114
2
Va
02137-8P5
R29
8.2K
1
2
3
VDD
VCC
GND
4
U1
8
JP3
100uF/16V
S-C63MM
02237-0AF
1
2
3
4
02137-8J8
V2.5
R4
R125 TEMP
0
02137-8J8
0
2
-
1
C5
0.1U
02237-C05
TO IR BOARD
IR0
IR0
5,15
P3P3V
100
02137-8F1
IR1
R187
10K
02137-8H7
CN1
1
2
3
P3P3V_STBY_PWR
2,5,13,17
CWINDEX 5,11
LM393
02037-ABF
R10
10K
02137-8H7
Pitch1.25/90deg
R118
10K
02137-8H7
R117
2,5,13,17
U19A
100K
02137-814
0.01uF 0.01uF
0
02137-8J8
5,15
R32
10K
02137-8H7
R24
10K/NC
10K/NC
02137-8H7 02137-8H7
SCL0
+
MAX2500GL
PLCC8D
02037-0G4
C37
R27
02237-26102237-261
SDA0
C23
+
0.1U
02237-C05
8
U3
6
5
C240
P5V_FILT
C6
R8
R31
0.1U R9
68K
4.7K
0
02237-C05
02137-8H5
0
02137-831
3
4
+
C233
C232
100uF/16V
0.1U
0.01uF
S-C63MM 02237-C05 02237-261
02237-0AF
0.1U
02237-C05
8
R113
7
P3P3V
+
CN7
1
2
3
R181
P3P3V_STBY_PWR
C253
100
02137-8F1
4x1/1.5mm
10uF/16V
02237-512
+
4x1/1.5mm
C288
10uF/16V
02237-512
P3P3V_STBY_PWR
02237-C05
L13
C319
C194
C309
C310
0.1U
02237-C05
02237-C05
C3110.1U
02237-C05
0.1U
TP32
T2OUT
TP30
R189
0 02137-8J8
C308
0.1UU13
02237-C05
1
C1+
2
V+
3
C14
C2+
5
C26
V7
T2OUT
8
R2IN
0.01uF
02237-261
10uF C193
02237-2C8
0.1U
VCC
GND
T1OUT
R1IN
R1OUT
T1IN
T2IN
R2OUT
16
15
14
13
12
11
10
9
10uH
L-GSR74B
02337-46H
TP33
TP31
P1P5V_STBY
R193
R194
100R
100R
TX1
RX1
RX1
02137-8F1
UART1_CTS
UART1_RTS
C320
47pF
UART1_CTS 5
UART1_RTS 5
ADM3202
SSOP16-25
02037-0D2
C321
47pF
02237-256
15
02137-8A0
02237-256
R140
24.9K, 1%
R104
0 02137-8J8
T2OUT
5 UART1_RXD
5 UART1_TXD
UART1_RXD
1
3
2
4
R2IN
R2IN
02137-1EA
15
P3P3V
02237-283
C335
0.1uF
2X2/2.54-NC
UART1_TXD
U46
SDA0
SCL0
1
2
3
4
8
SDA VDD
7
SCL
A0
6
INT
A1
5
GND
A2
LM75DM-33R2
02037-AAA
TC2
62
C258
R139
1K, 1%
JP2
R2IN
P3P3V_STBY
P2P5V_STBY
PJ402D-2
P3P3V_STBY
U26
1
2
3
4
0.1U
8
SENSE1 02237-C05
VCC
7
SENSE2
/MR
6
SENSE3 RESET
5
GND
/RESET
TPS3307
C345
0.1U/NC
02237-C05
POSENSE
VIDEO DECODER
7 TDO1_OUT
7
TCK
7
TDO1
7
TMS1
V3.3V
C263
C73
47n
02237-2CH
+
33uF/6.3V
02237-547
R133
10K/NC
02137-8H7
AGND
C127
33uF/6.3V
02237-547
34
35
VREF
FIELD
37
36
HREF
TDO/LLC2/DACT
39
40
38
TCK
TDI
TMS
41
42
VIN3
ISGND
44
43
A3
RES
A2
SCL
A1
SDA
A0
B0
AGND
11
VSS
12
AGND
C268
0.1U
02237-C05
+
P2_FIELD 4
33
32
P2_Y[7..0] 4
31
PR1
30
33uF/6.3V
02237-547
29
C257
28
1
2
3
4
5
6
7
8
V3.3V
C262
0.1U
02237-C05
+
27
16
15
14
13
12
11
10
9
P2_Y7
P2_Y6
P2_Y5
P2_Y4
P2_Y3
P2_Y2
P2_Y1
P2_Y0
26
33,1/16W,5%
25
02137-927
24
23
OE
V3.3V
PVSS
LLC
02137-8RJ
10
P2_VSYNC 4
P2_FIELD
R146 22
02137-8M0
22
9
PIXCLK
VDD
21
R55
75 1n
R0603
VPX322XE
XTAL2
VACT
C137
330p
02237-2CL
PVDD
B7
7
A4
U8
XTAL1
20
C138
330p
02237-2CL
AGND
6
8
02337-B03
V3.3V
3
AGND
R155
1M
Y3
AGND
C119
20.25MHz
02237-254 22p C269
AVDD
19
3N593
5
02237-254
B6
L11
CS1008-2R2-S
AGND
A6
A5
18
C139
0.1U
02237-C05
AGND
P2_HSYNC 4
P2_VSYNC
R138
10K/NC
02137-8H7
A7
CIN
B5
4
AGND
AGND
AVSS
B4
C270
22p
02137-8RJ
SVID_CHR
CON8 02461-0000-00
3
VIN1
17
AGND
C135
330p
02237-2CL
2
AGND
16
C136
330p
02237-2CL
1
R54 C118
75
680n
R0603 02237-2GS
B3
02337-B03
SVID_LUM
B2
1
2
3
4
5
6
7
8
AGND
AGND
15
L10
CS1008-2R2-S
AGND
33uF/6.3V
02237-547
02137-8RJ
AGND
AGND
3N594
14
J3
C120
0.1U
02237-C05
+
VRT
AGND
C272
VIN2
COMPVID
C133
330p
02237-2CL
DEC_AVDD
DEC_AVDD
B1
C134
330p
02237-2CL
R53 C117
75
680n
R0603 02237-2GS
13
02337-B05
P2_HSYNC
R14922
02137-8M0
R14322
02137-8M0
R14122
02137-8M0
AGND
AGND
3N591
L9
CS1008-3R3-S
P2_CLK
C261
22p/NC
02237-254
2,5,13,16 SCL0
2,5,13,16 SDA0
3
I2C_SDA
22
02137-8M0
R41
10K
02137-8H7
RESET-
0
R156
0 /NC
PR2
33,1/16W,5%
02137-927
02137-8J8
R142
P2_CLK
NC
P2_ACTDATA 4
1
P2_UV0
P2_UV1
P2_UV2
P2_UV3
P2_UV4
P2_UV5
P2_UV6
P2_UV7
2
U6
AIC1117-3.3
TO-252-AOI
+5V
+5V
S-VIDEO
L3
5
3
02037-CA8
BAV99L
D17
3
1
6
1
8
AGNDC
SVDOY
AGNDC
SVDOC
J15
1
2
3
4
5
6
7
8
MI0603J680R
C60
C72
0.1U
33uF/6.3V
02237-C05 02237-547
C71
0.1U
02237-C05
0R/0805
AGND
AGNDC
AGNDC
63
+
FB1
C325
0.1U
02237-C05
2
MI0603J680R
DEC_AVDD
2
CON8 02461-0001-00
L27
1
1
PJ402D-2
C29
0.1uF
C28
10uF
+ TANAD
VI
VO
A
CON3
I
V3.3VC
2
2
V3.3VC
ADJ
P2_UV[7..0] 4
V3.3VC
3
P2_CLK 4
P2_ACTDATA
R14822
02137-8M0
CVBS_AV_A
AGNDC
02037-CA8
BAV99L
D18
OE
R42 22
02137-8M0
1
2
3
4
5
6
7
8
1
OCLKB
OCLKB
02037-CA8
BAV99L
D16
CVBS
R165
16
15
14
13
12
11
10
9
2
8
CON2
I2C_SCL
22
02137-8M0
EXT_ARSTZ R162
5,10,11 EXT_ARSTZ
V3.3VC
R166
AGND
TAB
V3.3V
V3.3V
O
4
C61
0.1uF
C53
10uF
+ TANAD
C285
C280
33uF/6.3V
02237-547
+
0.1U
02237-C05
C284
0.1U
02237-C05
DESIGN NOTE
UA2
CNA1
JA1
RA1
NC
1
2
3
4
3
2
1
3
2
1
RA2
220
02137-880
1
2
3
VOUT
GND
VCC
4
2
3x1_1.50mm_PTH
IS1U60
TO220-IRM
UA1
TMT-12501RP-04
02437-GDG
P1637-006 / FRONT IR PCB
1
3
GP2S27T2
02037-EAH
CA1
0.1UF
02237-283
UA3
CNA2
GND7
3
2
1
3
2
1
1
2
3
VOUT
GND
VCC
3x1_1.50mm_PTH
IS1U60
TO220-IRM
RA4
47K
02137-877
RA5
220
02137-880
P1637-005 / BACK IR PCB
UA5
CNA3
2
3
JA2
1
2
3
4
3
2
1
UB1
3
2
1
1
2
3
VOUT
GND
VCC
3x1_1.50mm_PTH
1
4
GP2S700
CA3
0.1UF
02237-283
02437-68D
TMT-12501RP-04
02437-GDG
IS1U60
TO220-IRM
02026-0004-00
P2037-001 / ACER FRONT IR PCB
GND6
JP1A
CA2
TC1
1
2
3
4
IL-Z-4PL-SMTY
SCL1
0.1uF
R3A
1k
02137-8F3
UA4
SDA1
1
2
3
4
8
SDA VDD
7
SCL
A0
6
INT
A1
5
GND
A2
LM75DM-33R2
02037-AAA
GND3
64
PJ402D-2
Chapter 9
Recommended Spare Parts List
RECOMMENDED SPARE PARTS LIST (PJ402D-2)
ViewSonic Model Number: VS10040
Rev. 1f
Serial No. Prefix: Q3V
Item
Description
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
REMOTE CONTROLLER
POWER CORD (AUSTRALIA)._(SAA)YP-35/YC-12_YUNG LI_ROHS
POWER CORD(UK)._YP-61/YC-12_YUNG LI_ROHS
POWER CORD(CHINA)._YP-03/YC-12_YUNG LI_ROHS
POWER CORD(USA)._UL(YP-12/YC-12)_YUNG LI_ROHS
POWER CORD(EUROPE)._YP-22/YC-12_YUNG LI_ROHS
LAMP MODULE
MAIN BOARD( INCLUDE VIDEO/BOARD )
Main Board with Updated Firmware P4137965_C_06_06_13_S611_Viewsonic
USHIO BALLAST
PC Board Assembly: PD-S600 PFC, POWER
PD-S600 KEYPAD+METAL DOME
[All PCBA]
FIR_DIP_PCB_ASY_PD-S610_ROHS
BIR_DIP_PCB_ASY_PD-S610_ROHS
PD-S600 THERMAL PCB
BACK IR COVER
BOTTOM COVER
FRONT COVER ( PD-S611 )
Cabinets: [Front
LAMP COVER + ISOLATOR
Panel, Back Cover,
TOP COVER MODULE
Base]
FRONT IR COVER
IO COVER
LENS COVER
WIRE CON-CON 2P 380V
WIRE CON-CON 2P AC SOCKET
WIRE CON-CON 3P IR/F
WIRE CON-CON 3P BST
FFC CABLE 0.5P 28P
WIRE CON-CON 4P C/W
WIRE CON-CON 3P IR/R
WIRE CON-CON 5P BST
Cables: [All Cables]
CONN WIRE_4PIN MCU
Accessories:
[Adapter, Remote
Control]
33
WIRE CON-CON 12P-10+2P PWR BD
34
35
36
37
38
39
Documentation:
40
Electronic
41
Components: [CRT42 EEPROM, Fly Back
43 Transformer,
44
45
46
47
48
49
50
Hardware: [Screw,
51
Bracket, Hinge]
52
CONN WIRE_10PIN MCU
CONN WIRE_5PIN MCU
CONN WIRE_2PIN MCU
PHONE TO 2 RCA CABLE_L2000._A9108054_SINBON_ROHS
RCA CABLE._933211000056_MPT_ROHS
Quick Start Guide
User Guide
SPEAKER
OPTICAL ENGINE without LAMP (PD-S611)
COLORWHEEL MODULE-SHINANO
S: M3*28.5*E1.2 BL
SHD-PWR-BD-PD-S600
S:M3*6*D2 BL NL D=5.5
SCREW_3*5*A2_D=5.3_BLACK_ROHS
HEXAGON-HEAT-BOLT-4.8_PJ-X900_3M_ROHS
SCREW_M3*12*A2_D=5.3_NI_NL_ROHS
SCREW_2*4*E0.5_D=4_BLACK_ROHS
SCREW-WASHER_M3*8*D2_D=5.5_BLACK_ROHS
53
SCREW_4*10*A2.5_D=6_NI_ROHS
54
S:M3*10*A2 NI
LF*55
S: M1.7*2 BL
56
WSC:8*4.3*1FE/NI S-GTY
57
S:M4*6*A3 NI
HK*58
S:M3*6*D2 BL
FAN
59
60 Miscellaneous:
FAN MODULE_PD-S600
61 [Switch, Fan, Rubber MESH
62 Foot, Logo]
MYLAR-POWER-BD-PD-S600
63
FAL3F12LLSC ASSY
64
UV-IR_PD-S600_ROHS
65
EPE FOR PD-S600
Packing Material:
66
SILICA GEL DESICCANT
[Box, Foam]
67
CARTON_PJ402D-2_USA
68
FOOT ASSEMBLY
69 Plastics:
FUNCTION KEYSTROKE
70 [All Covers: Dust,
KEYSTROKE
71 Cable, Hinge covers] CARTON PAD
ECR/ECN
Replaced on 11/28/2008 per ECR#VS-E080372
Added on 11/28/2008 per ECR#VS-E080372
VS-E060448/Updated
and replaced on 12/14/06
Updated on 11/28/2008 per ECR#VS-E080372
Updated on 11/28/2008 per ECR#VS-E080372
VS-E080399 Added on 11/26/08
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 06/01/06
Added 01/04/05
Added 01/04/05
Replaced on 11/28/2008 per ECR#VS-E080372
ViewSonic P/N
A-00003062
A-00008053
A-00008060
A-00008058
A-00008056
A-00008059
A-00008057
RLC-014
B-00004674
B-00008249
B-00004675
B-00004676
B-00004677
B-00004678
B-00004679
B-00004680
C-00003070
C-00003071
C-00003072
C-00003075
C-00004681
C-00004682
C-00004683
C-00004684
CB-00003084
CB-00003085
CB-00003087
CB-00003088
CB-00004685
CB-00004686
CB-00004687
CB-00004688
CB-00004689
CB-00004690
CB-00004691
CB-00004692
CB-00004693
CB-00008064
CB-00008462
DC-00006277
DC-00006278
E-00003094
E-00004774
E-00009051
HW-00003097
HW-00003105
HW-00004836
HW-00004837
HW-00004839
HW-00004840
HW-00004841
HW-00004842
HW-00004843
HW-00005969
M-SCW-0824-6912
M-SCW-0824-6913
M-SCW-0824-6916
M-SCW-0824-6918
M-SCW-0824-6923
M-00008266
M-00003102
M-00003103
M-00003104
M-00004772
M-00004773
P-00003108
P-00008880
P-00004844
PL-00003113
PL-00003114
PL-00003115
P-00003110
PL-00008100
Ref. P/N
82143-4000
P1600-RC02
J2552-0053-00
J2552-0108-00
J2552-0106-00
J2552-0109-00
J2552-0107-00
P4184-1005
P3584-1002
P4184-1010
P4184-1001
P4184-1007
P4184-1006
P3247-5100
P3247-5101
P3634-7400-00
P1634-462
P1684-0004
P1684-0002
P1643-0013
P3484-1003
P1634-461-99
P1634-465-99
P1634-458-99
02595-0019-00
02595-0028-00
02595-0016-00
02595-0027-00
02591-0014-00
02595-0018-00
02472-0016-00
02595-0030-00
02472-0017-00
02595-0063-00
J2595-0063-00
02472-0006-01
02472-0014-00
02472-0015-00
J2552-0111-00
J2552-0075-00
P4139-7013-00
P4139.A006.00
02413-0016-00
J2413-0016-00
P4184-1008
P1643-0008
01635-C98-N
P1635-052
01635-B77-N
01635-3610-00
82035-2510-00
01635-C010-00
01635-3530-00
01635-A441-00
01635-D360-00
01635-A011-00
01635-365
01635-366
01635-705
01635-A08
01635-B77
J2394-0011-01
P1643-0021
P1638-156
P1638-150
02394-0011-01
P1636-7640-00
04039-544
J4039-R128-01
P4139-6002-00
P1643-0012
P1634-460
P1634-459
P1639-690
P1639-R690-00
Location Universal number#
Remark 1: Above listed items are examples, supplier can expand the rows to add more necessary items.
Remark 2: All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to eliminate repeated cross checks of each item
between this version and prior versions.
65
PJ402D-2
BOM LIST (PJ402D-2)
ViewSonic Model Number: VS10040-2W
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
Rev: 1a
(for RoHS issue)
Serial No. Prefix:Q3V
ViewSonic P/N
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
HW-00004841
HW-00004837
N/A
N/A
N/A
N/A
N/A
HW-00005969
N/A
HW-00004842
N/A
N/A
N/A
N/A
HW-00004840
N/A
N/A
N/A
HW-00004843
Ref. P/N
01496-3008
P2236-7710-00
P3247-5002
P4236-7630-00
01496-3003-00
01635-0780-00
01635-0780-00
01635-0860-00
01635-1010-00
01635-2250-00
01635-2660-00
01635-3530-00
01635-3610-00
01635-3620-00
01635-3630-00
01635-3650-00
01635-3660-00
01635-7050-00
01635-A011-00
01635-A080-00
01635-A441-00
01635-A660-00
01635-B592-00
01635-B770-00
01635-B770-00
01635-C010-00
01635-C980-01
01635-D100-00
01635-D311-00
01635-D360-00
Description
BOROFLOAT GLASS 80X88X2.75MM_XXPTBU_ROHS
COLOR-WHEEL_TOD-S601_RoHS
CW-SENSOR_SMT_PCB_ASY_PD-S610_ROHS
LIGHT TUNNEL -5.2*3.8_PD-X611_ROHS
BOROFLOAT 850X575X+/-10MM T:2.75+/-0.2MM
SCREW_M2*2.5*A0.8_D=3_BLACK_ROHS
SCREW_M2*2.5*A0.8_D=3_BLACK_ROHS
SCREW_1.2*2*A0.4_D=2_BLACK_ROHS
SCREW_M1.4*2.5*A0.5_D=2.5_BLACK_ROHS
SCREW_M2*5*A0.8_D=3_BLACK_ROHS
SCREW_1.7*4*A0.5_D=4_BLACL_ROHS
SCREW_2*4*E0.5_D=4_BLACK_ROHS
SCREW_3*5*A2_D=5.3_BLACK_ROHS
SCREW-WASHER_3*6*D2.6_D=5.4_NI_ROHS
SCREW_M3*24*A2_D=5.3_BLACK_ROHS
SCREW_M3*10*A2_D=5_NI_ROHS
SCREW_M3*5*D2_D=5.5_NI_ROHS
WASHER_ELASTIC_CLOSE:8*4.3*1_FE_NI _ROHS
SCREW_4*10*A2.5_D=6_NI_ROHS
SCREW_M4*6*A3_D=6.7_NI_ROHS
SCREW_M2*10*A1.3_D=3_NI_ROHS
SCREW_M1.8*5*A1.0_D=3.5_BLACK_ROHS
SCREW_M3*6*D2_D=5.5_BLACK_NL_ROHS
SCREW_M_3_8_E_1.2_6.5_BLACK_NL_ROHS
SCREW_M2*2.5 A0.8_D=3.5_BLACK_ROHS
SCREW_M3*7.1*E1.2_D=6_NI_ NL_ROHS
31
32
N/A
N/A
02001-0027-00
SWITCHING DIODE_SOT-23_BAV99-7-F_DIODES_ROHS
02001-0028-00
33
34
35
36
37
38
N/A
N/A
N/A
N/A
N/A
N/A
39
40
41
42
N/A
N/A
N/A
N/A
43
N/A
44
N/A
SWITCHING DIODE_SOT-23_BAV70TR_PANJIT_ROHS
ZENER DIODE_UMD2_UDZSTE172.0B_ROHM_VZ=2.0V_ROHS
ZENER DIODE_LL-34_RLZTE-118.2B_ROHM_ROHS
SCHOTTKY DIODE_SMB_SBM22PT_CHENMKO_ROHS
SCHOTTKY DIODE_SOD-123_B0540W-7-F_DIODES_ROHS
SCHOTTKY DIODE_SOT-323_BAT54SW_PHILIPS_ROHS
RECTIFIER_PMDS_1SR154-400TE25_ROHM_ROHS
CHIP LED_L2.7*W3.4*H1.5_KA-2734SGECF01_KINGBRIGHT_GREEN+RED_ROHS
TR NPN_SST3_SST2222AT116_ROHM_ROHS
TR PNP_SOT89_PBSS5350X_PHILIPS_ROHS
TR PNP_SST3_SST2907AT116_ROHM_ROHS
TR MOSFET_SOT-23_P-CHANNEL_AO3401L_ALPHAOMEGA_ROHS
TR MOSFET_SOT-23_N-CHANNEL_FDV301NNL_FAIRCHILD_ROHS
TR MOSFET_P-CHANNEL_S0T223_IRFL9014TRPBF_IR_ROHS
PHOTO INTERRUPTER_GP2S27T2J00F_SHARP_ROHS
IR RECEIVER_FM-6038LN-5AN_OPTO-SENSOR_ROHS
IR RECEIVER_FM-6038LN-5AN_OPTO-SENSOR_ROHS
TEMPERATURE SENSORS_MSOP8_LM75CIMM-3
NOPB_NS_ROHS
K4R271669F-TCS8,62BGA RDRAM,SAMSUNG_ROHS
EEPROM_SOIC8_24LC08BT-I-SN_MICROCHIP_8KBIT_ROHS
EEPROM_SOIC8_24LCS21AT-SN_MICROCHIP_1KBIT_ROHS
FLASH MEMORY_48TSOP_S29AL016M90TFI02090EI_SPANSION_1M*16_ROHS
OSCILLATOR_6N50000267_TXC_50MHZ_ROHS
CRYSTAL_HC-49/S_9C20200024_TXC_20.25MHZ_ROHS
DUAL COMPARATOR_SOIC-8_LM393MX_NS_ROHS
AUDIO AMP_TSSOP-24_TPA0172PWPRG4_TI_ROHS
LINEAR REGULATOR_TO-263_AIC1084-25PMTR_AIC_LEADFREE
LINEAR REGULATOR_TO-263_AIC1084-33PMTR_AIC_LEADFREE
45
46
47
48
N/A
N/A
N/A
N/A
49
50
51
52
N/A
N/A
N/A
N/A
53
54
55
56
57
N/A
N/A
N/A
N/A
N/A
58
N/A
59
N/A
02002-0011-00
02002-0015-00
02003-0022-00
02003-0031-00
02003-0042-00
02004-0009-00
02005-0078-00
02011-0044-00
02012-0012-00
02012-0024-00
02013-0025-00
02013-0029-00
02013-0064-00
02023-0008-00
02026-0003-00
02026-0003-00
02029-0010-00
02032-0008-09
02033-0010-01
02033-0017-00
02034-0016-03
02041-0007-00
02042-0034-00
02051-0027-00
02051-0030-00
02052-0038-01
02052-0053-00
Location
Universal number# Q'ty
D10 D11 D12 D13
D16 D17 D18 D25
D9
ZD2
D23
D8 D14
D1 D2 D3 D4
D15
Q5 Q9 Q10 Q14
Q3
Q6 Q11 Q12 Q15
Q1
Q4 Q7 Q8 Q13
D6 D21 D22 D24
U46
U20
U18
U36
U14
Y2
Y3
U19
U2
U15
U7 U44
66
PJ402D-2
Item
ViewSonic P/N
60
N/A
61
N/A
62
N/A
63
64
N/A
N/A
65
66
67
N/A
N/A
N/A
68
69
N/A
N/A
70
N/A
71
72
73
74
75
76
N/A
N/A
N/A
N/A
N/A
N/A
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
94
Ref. P/N
02078-0000-01
02080-0014-01
02081-0012-01
02112-1100-00
02112-2492-01
Description
LINEAR REGULATOR_TO-252_AIC1117-33PETR_AIC_LEADFREE
LDO REGULATOR_SOT-223_SC1565IST1.8TRT_SEMTECH_1.8V_ROHS
RS232 DRIVER RECEIVER_TSSOP-16_ADM3202ARUZREEL_ANALOG DEVICES_ROHS
ADC_LQFP-80P_AD9883AKSTZ-140_ANALOG
DEVICES_ROHS
RESET IC_SO-8_TPS3307-25DR_TI_2.5V_ROHS
VIDEO PIXEL DECORDER_PMQFP44_VPX3226F_MICRONAS_ROHS
PWM CONTROL CIRCUIT_SO-8_TL5001ACDRG4_TI_ROHS
MOTOR DRIVER_SOIC-24_A8904SLB-T_ALLEGRO_ROHS
2-INPUT POSITIVE-AND GATES_TSSOP14_SN74HCT08PWR_TI_ROHS
CLOCK GENERATOR_SSOP-24_CDCR83DBQR_TI_ROHS
SINGLE INVERTER GATE_SOT235_SN74LVC1G04DBVR_TI_ROHS
BUS BUFFER GATE_SOT235_SN74AHC1G125DBVR_TI_ROHS
SCALER_564PBGA_DDP2000_2504504-3_TI_ROHS
CPU-OTP ROM_SOIC14_PIC16F630-I-SL_MICROCHIP_ROHS
ASIC IC_PFP80_DAD1000_2503253-0004_TI_ROHS
CHIP RESISTOR_110_1%_1/16W_0402_ROHS
CHIP RESISTOR_24.9K_0402_1%_1/16W_ROHS
02113-1001-00
CHIP RESISTOR_1K_0603_1%_0.1W_ROHS
02113-1100-00
02113-1180-00
02113-220Z-00
02113-3012-00
02113-3301-00
02113-330Z-00
02113-340Z-00
02113-390Z-00
02113-4990-00
02113-562Z-00
02113-5900-00
02113-6042-00
02113-6202-00
02113-750Z-00
02113-8201-00
02152-0000-01
CHIP RESISTOR_110_0603_1%_0.1W_ROHS
CHIP RESISTOR_30.1K_0603_1%_0.1W_ROHS
CHIP RESISTOR_56.2_0603_1%_0.1W_ROHS
CHIP RESISTOR_0_0402_5%_1/16W_ROHS
02153-0000-01
02153-0000-01
02153-0101-00
02153-0101-00
02052-0054-00
02052-0110-00
02053-0001-00
02054-0016-00
02055-0016-01
02057-0008-01
02059-0011-01
02060-0016-00
02071-0039-00
02075-0002-00
02076-0013-00
02076-0014-01
N/A
95
96
97
N/A
N/A
N/A
98
N/A
02153-0102-01
CHIP RESISTOR,1K,5%,1/10W,0603,ROHS
99
N/A
02153-0102-01
02153-0103-00
100
N/A
02153-0103-00
101
102
103
104
105
106
N/A
N/A
N/A
N/A
N/A
N/A
02153-0104-00
02153-0105-00
02153-0122-00
02153-0152-00
02153-0202-00
CHIP RESISTOR,1M,5%,1/10W,0603,ROHS
CHIP RESISTOR,1.2K,5%,1/10W,0603,ROHS
02153-0220-00
107
108
109
N/A
N/A
N/A
02153-0221-00
02153-0270-00
CHIP RESISTOR,220,5%,1/10W,0603,ROHS
Location
U6 U9 U23 U27
U30
U4
U13
U10
U26
U8
U24
U5
U47
U17
U25
U28 U34 U35 U45
U11
R124
R140
R26 R71 R74
R139 R158 R163
R39 R123
R25
R50 R176 R185
R144 R145
R100
R90 R91
R21
R6 R7
R151
R33 R34
R150
R136
R245
R168 R169 R170
R268
R9 R12 R18 R41
R42 R65 R67 R68
R85 R104 R108
R116 R126 R152
R162 R175 R182
R186 R189 R218
R9 R12 R18 R41
R42 R65 R67 R68
R85 R104 R108
R116 R126 R152
R162 R175 R182
R186 R189 R218
R194
R194
R5 R14 R15 R16
R35 R64 R178
R5 R14 R15 R16
R35 R64 R178
R10 R13 R19 R32
R106 R107 R109
R112 R118 R159
R10 R13 R19 R32
R106 R107 R109
R112 R118 R159
R24 R134 R135
R155
R262
R94 R273
R177 R179
R52 R63 R70 R72
R75 R77 R141
R143 R146 R148
R96 R97
67
PJ402D-2
Item
110
ViewSonic P/N
N/A
Ref. P/N
02153-0271-10
111
N/A
02153-0330-00
112
113
N/A
N/A
02153-0332-00
02153-0470-10
02153-0472-00
114
115
N/A
N/A
116
117
N/A
N/A
118
119
N/A
N/A
120
N/A
121
N/A
122
N/A
123
N/A
124
N/A
125
N/A
126
N/A
127
N/A
02153-0683-00
02155-0000-01
02155-0151-00
02158-0220-00
02158-0330-00
02158-0390-00
02158-0472-00
02202-0680-00
02203-0100-00
02203-0102-01
02203-0103-02
02203-0104-01
02203-0104-02
02203-0104-05
128
N/A
CHIP RESISTOR 270
Description
5% 1/10W 0603
Location
LEAD-FREE
R164 R173 R174
R238 R239 R240
R30 R43 R48 R49
R93 R157 R250
R171
R31 R83 R84
R101 R244 R264
R265 R266 R272
R302R 303 R296
R8
FB1 R122 R127
R129 R180 R183
R119 R120 R121
PR11 PR12 PR14
RESISTOR ARRAY SMD_22*8_0602_5%_0.063W_16P8R_ROHS
PR15 PR16
RESISTOR ARRAY SMD_33*8_0402_5_0.063W_ROHS
PR10 PR13
PR3 PR4 PR5 RP2
RESISTOR ARRAY SMD_39*8_0402_5%_0.063W_16P8R_ROHS
RP3 RP4
RESISTOR ARRAY
SMD_4.7K*8_0402_5%_0.063W_16P8R_ROHS
RP1
CERAMIC CAP
C15 C16 C25 C26
SMD_68PF_50V_0402_T0.55MM_NP0_5%_ROHS
C69 C81
CERAMIC CAP
C249
CERAMIC CAP
C7 C9 C10 C119
SMD_1000PF_50V_0603_T0.9MM_X7R_10%_ROHS
C165 C346
CERAMIC CAP SMD_0.01UF_50V_0603_T0.9MM_Y5V_+80/20%_ROHS
C194 C256
CERAMIC CAP
SMD_0.1UF_16V_0603_T0.9MM_X7R_10%_ROHS
CERAMIC CAP
C290 C295 C314
C315 C2 C5 C6
C13 C14 C17 C18
C20 C22 C24 C27
C29 C30 C32 C33
C34 C39 C40 C45
C47 C48 C52 C55
C56 C57 C58 C59
C60 C61 C71 C74
C75 C76 C77 C78
C79 C80 C82 C83
C84 C85 C86 C87
C88 C89 C90 C91
C96 C97 C99
CERAMIC CAP
C101 C102 C103
C104 C105 C109
C111 C112 C113
C114 C115 C116
C120 C121 C122
C123 C124 C125
C126 C128 C130
C131 C132 C140
C141 C142 C143
C144 C145 C146
C147 C148 C149
C150 C153 C154
C155 C156 C157
C158 C160 C162
68
PJ402D-2
Item
ViewSonic P/N
Ref. P/N
02203-0104-05
129
N/A
130
N/A
131
N/A
132
N/A
133
N/A
134
N/A
135
N/A
136
N/A
137
N/A
138
N/A
139
N/A
140
N/A
141
N/A
142
N/A
143
N/A
144
N/A
145
N/A
146
N/A
147
N/A
148
N/A
149
N/A
150
N/A
151
152
N/A
N/A
02203-0220-00
02203-0272-00
02203-0330-00
02203-0331-01
02203-0332-00
02203-0393-00
02203-0470-00
02203-0472-00
02203-0473-00
02203-0473-10
02203-0474-01
02203-0680-00
02203-0684-00
02204-0224-02
02204-0392-00
02204-0474-02
02205-0106-02
02206-0105-01
02212-0105-01
02212-0105-02
02212-0106-00
02212-0106-00
02212-0106-03
Description
Location
C290 C295 C314
C315 C2 C5 C6
C13 C14 C17 C18
C20 C22 C24 C27
C29 C30 C32 C33
C34 C39 C40 C45
C47 C48 C52 C55
C56 C57 C58 C59
C60 C61 C71 C74
C75 C76 C77 C78
C79 C80 C82 C83
C84 C85 C86 C87
C88 C89 C90 C91
C96 C97 C99
C101 C102 C103
C104 C105 C109
C111 C112 C113
C114 C115 C116
C120 C121 C122
C123 C124 C125
C126 C128 C130
C131 C132 C140
C141 C142 C143
C144 C145 C146
C147 C148 C149
C150 C153 C154
C155 C156 C157
C158 C160 C162
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
SMD_330PF_50V_0603_T0.9MM_C0G_5%_ROHS
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
SMD_68PF_50V_0603_T0.9MM_C0G_5%_ROHS
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP
CERAMIC CAP SMD_10UF_10V_1206_T1.8MM_Y5V_+80/20%_ROHS
CERAMIC CAP
SMD_1UF_50V_1210_T2.7MM_X7R_10%_ROHS
TANTALUM CAP SMD_1UF_16V_A
CASE_T1.8MM_20%_ROHS
CASE_T1.8MM_20%_F931C105MAA_NICHICON_ROHS
C269 C270
C21 C62
C259
C133 C134 C135
C136 C137 C138
C260
C201
C320 C321
C63
C152 C161 C179
C73
C4 C41 C42 C43
C44 C46 C242
C340 C343
C117 C118
C66
C202
C1
C193
C64 C200
C3 C28 C53 C65
C93 C98 C100
C106 C108 C129
CASE_T1.8MM_20%_TEESVA1A106M8R_NEC_ROHS
C164 C168 C214
C3 C28 C53 C65
C93 C98 C100
C106 C108 C129
CASE_T1.8MM_20%_TEESVA1A106M8R_NEC_ROHS
C164 C168 C214
TANTALUM CAP SMD_10UF_16V_A CASE_T1.8MM_20ROHS C188 C255 C317
69
PJ402D-2
Item
153
ViewSonic P/N
N/A
154
N/A
155
N/A
156
N/A
157
158
N/A
N/A
159
N/A
160
N/A
161
N/A
162
N/A
163
N/A
164
N/A
165
N/A
166
N/A
167
N/A
168
N/A
169
N/A
170
N/A
171
N/A
172
N/A
173
N/A
174
N/A
175
N/A
176
177
178
179
180
181
182
N/A
N/A
M-00004772
N/A
N/A
N/A
E-00003094
183
N/A
184
N/A
185
N/A
186
N/A
187
N/A
188
189
190
191
192
N/A
N/A
CB-00004691
CB-00004692
CB-00004693
Ref. P/N
02212-0106-03
02212-0336-00
02212-0336-00
02214-0107-00
02215-0107-00
02217-0476-00
02251-0107-01
02251-0107-02
02251-0337-00
02251-0476-07
02304-0225-01
02304-0335-00
02306-0225-00
02313-0010-00
02313-0012-00
02313-0012-00
02314-0010-00
02314-0012-00
02319-0003-00
02346-0029-00
02346-0055-00
02346-0069-00
02346-0071-00
02346-0093-00
02394-0003-01
02394-0011-01
02394-0023-00
02405-0036-00
02405-0068-00
02413-0016-00
02452-0078-00
02452-0079-00
02461-0000-01
02461-0001-01
02471-0071-01
02471-0071-01
02471-0136-00
02472-0006-01
02472-0014-00
02472-0015-00
Description
Location
TANTALUM CAP SMD_10UF_16V_A CASE_T1.8MM_20ROHS C188 C255 C317
C257 C263 C272
TANTALUM CAP SMD_33UF_6.3V_A CASE_T1.8MM_20ROHS
C280 C286 C287
TANTALUM CAP SMD_33UF_6.3V_A
C257 C263 C272
CASE_T1.8MM_20_ROHS
C280 C286 C287
TANTALUM CAP SMD_100UF_6.3V_B2
C19 C159 C234
CASE_T2.1MM_20ROHS
C254 C38 C110
TANTALUM CAP SMD_100UF_10V_C
CASE_T2.7MM_20ROHS
TANTALUM CAP SMD_47UF_20V_D CASE_T3.0MM_20ROHS C107 C332
ELECTROLYSIC CAP
SMD_100UF_25V_D8*L6.5_ALU_20%_RV-100M25V0806EU_ELNA_ROHS
C186 C215
ELECTROLYSIC CAP
C49 C50 C68 C95
SMD_100UF_16V_D6.3*L5.3_ALU_20%_RV2-16V101MSUC187 C329 C330
R_ELNA_ROHS
C333
ELECTROLYSIC CAP
SMD_330UF_6.3V_L10.1*W4.6*H4.6_ALU_20%_SE0J3314B_SHOEI_ROHS
C296 C303
ELECTROLYSIC CAP
SMD_47UF_25V_D6.3*L5.3_ALU_20%_RV2-47M25V6353EU_ELNA_ROHS
C211
CHIP INDUCTOR_2.2UH_0805_T1.1MM_10%_FLMA-2012092R2K-T_KING CORE_ROHS
L10 L11
CHIP INDUCTOR_3.3UH_0805_T1.1MM_10%_FLMA-2012093R3K-T_KING CORE_ROHS
L9
CHIP INDUCTOR_2.2UH_1210_T2.4MM_5%_NLV32T-2R2JPF_TDK_ROHS
L14
CHIP FERRITE BEAD_120_0603_T0.95MM_25%_PBY160808T121Y-N_CHILISIN_ROHS
F1
CHIP FERRITE BEAD_68_0603_T0.95MM_25%_MI0603J680R- L12 L15 L18 L19
10_STEWARD_ROHS
L27
CHIP FERRITE BEAD_68_0603_T0.95MM_25%_MI0603J680R- L12 L15 L18 L19
10_STEWARD_ROHS
L27
CHIP FERRITE BEAD_60_0805_T1.1MM_25%_PBY201209T600Y-N_CHILISIN_ROHS
F2
CHIP FERRITE BEAD_120
L21 L22 L23 L32
OHM_0805_T1.2MM_25%_CH201209T-121Y_CTC_ROHS
L33
ESD SUPPRESSOR_0603_T0.6MM_1608SGXAESD1 ESD2 ESD3
TR1_PICO_ROHS
ESD4
POWER INDUCTOR_47UH_L5.1*W5.1*H3.0_PIH4D28470M_EROCORE_ROHS
FB2 L1
POWER INDUCTOR_47UH_L10.4*W10.3*H4.0_20%_RH104R470M_ASATECH_ROHS
L171
POWER INDUCTOR_10UH_L7.5*W7.5*H4.5_20%_RH74100MR_ASATECH_ROHS
L25
POWER
INDUCTOR_33UH_L5.0*W5.0*H3.0_30%_CDRH4D28NP330NC_SUMIDA_ROHS
L16 L28 L29 L31
POWER
INDUCTOR_22UH_L6.6*W4.54*H2.92_20%_SDT0402T-220MN_CHILISIN_ROHS
L20 L24
FAN_FBA06A12L4PX(WIRE=100MM)_PANAFLO_ROHS
FAN_BFB0512LD-F00-G_DELTA_ROHS
FAN_KDE1206PTV3-MS-M-GN_SUNON_ROHS
SLIDE SW_HDS404-021E_HCH_ROHS
SW1
DIP SW_NHDS-02-F-T-V-T/R_DIPTRONICS_ROHS
SPEAKER_PB28KC04-9-7 JS_VECO_ROHS
CONN B-B_0.5PITCH_120PIN_WR-120P-HF-HDA1E_JAE_FEMALE_ROHS
CONN B-B_0.5PITCH_120PIN_WR-120SB-VFN1_JAE_MALE_ROHS
J5
CONN B-B_2.54PITCH_8PIN_CPBA850R01X8L_CSE_FEMALE_ROHS
CONN B-B_2.54PITCH_8PIN_CPHA90001X8-1L_CSE_MALE_ROHS
CONN FPC_0.5PITCH_28PIN_FH12-28S0.5SH(55)_HIROSE_ROHS
CN2
CONN FPC_0.5PITCH_28PIN_FH12-28S0.5SH(55)_HIROSE_ROHS
CN2
CONN FPC_1.0PITCH_4PIN_52207-0485_MOLEX_TOP_ROHS J8
CONN WIRE_10PIN_S10B-PH-SM4-TB(LF)(SN)_JST_ROHS
J9
CONN WIRE_5PIN_SM05B-SRSS-TB(LF)(SN)_JST_ROHS
J1
CONN WIRE_2PIN_S2B-ZR-SM4A-TF(LF)(SN)_JST_ROHS
JP5
70
PJ402D-2
Item
193
194
195
196
197
198
199
ViewSonic P/N
CB-00004693
CB-00004687
CB-00004687
CB-00004687
CB-00004687
CB-00004689
CB-00004689
200
N/A
201
202
203
204
N/A
N/A
N/A
N/A
205
N/A
206
CB-00004685
207
CB-00003087
208
CB-00004686
209
CB-00003084
210
CB-00003088
211
CB-00003085
212
CB-00004688
213
214
215
216
217
218
219
220
221
222
223
224
225
226
227
228
229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
248
249
250
251
252
253
254
255
256
CB-00004690
N/A
HW-00004839
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Ref. P/N
02472-0015-00
02472-0016-00
02472-0016-00
02472-0016-00
02472-0016-00
02472-0017-00
02472-0017-00
02474-0034-00
02474-0036-00
02474-0048-00
02474-0061-00
02474-0092-00
02475-0003-10
02591-0014-00
02595-0016-00
02595-0018-00
02595-0019-00
02595-0027-00
02595-0028-00
02595-0030-00
02595-0063-00
04039-1400-00
82035-2510-00
82134-0660-00
82134-4640-00
82134-4640-99
82134-4650-00
82135-0540-00
82135-2510-00
82135-3010-00
82135-3510-00
P0335-7010-00
P0338-1010-00
P1634-2000-00
P1634-2010-00
P1634-2030-00
P1634-2040-00
P1634-2060-00
P1634-2070-00
P1634-2080-00
P1634-2090-00
P1634-2110-00
P1634-4500-0E
P1634-4500-99
P1634-4510-0E
P1634-4510-99
P1634-4520-0E
P1634-4520-99
P1634-4530-0E
P1634-4530-99
P1634-4540-0E
P1634-4540-99
P1634-4550-00
P1634-4550-99
P1634-4560-00
P1634-4560-99
P1634-4580-00
P1634-4580-99
P1634-4590-0E
P1634-4600-0E
P1634-4610-00
P1634-4610-99
P1634-4620-00
P1634-4630-00
Description
CONN_EARPHONE JACK_5PIN_EPJ-035-33A_NINTY
NINE_ROHS
CONN_S-VIDEO JACK_4PIN_MD-508BS-4_NINTY
NINE_ROHS
CONN_D-SUB JACK_15PIN_0401018-3_MSK_ROHS
CONN_USB JACK_KS-001-BNW_99 INC_ROHS
CONN_RCA JACK_RJ848Y-2RA_99 INC_ROHS
DMD 203PIN SOCKET_203PIN_J103U
SERIES_TELEDYNE_ROHS
FFC CABLE_CCAA28200GF07AA_PTWO_0.5PITCH_28PIN_L200MM_ROHS
WIRE CON-CON_110200311_MSK_3PIN_L70MM_1571#28_LEAD-REE
WIRE CON-CON_110200313_MSK_4PIN_L130MM_1571#28_ROHS
WIRE AC SOCKET-CON_110200316_MSK_2PIN_L70/L40MM_1015#18_ROHS
BAG_ACER_HDPE-EPE
HEXAGON-HEAT-BOLT-4.8_PJ-X900_3M_ROHS
PINGOOD-YJ90_PJ-700_00_ROHS
FOOT-HOUSING_PJ-700_00_ROHS
FOOT-HOUSING_PJ-700_00_ROHS
FOOT-BLOCK_PJ-700_00_ROHS
LOCK-SHEET_PJ-700_3M_ROHS
E-RING_PJ-700_3M_ROHS
LAMP-BAR_PJ-X700_00_ROHS
FOOT-SPRING_PJ-700_3M_ROHS
LAMP SCREW_PJ-X701_00_ROHS
REFLECTIVE TAPE_PJ-S701_ROHS
OE TOP CAP_PD-S600_00_ROHS
LAMP HAUSING_PD-S600_00_ROHS
OE C1 CAP_PD-S600_00_ROHS
WIND TUNNEL_PD-S600_00_ROHS
FAN1_BLOCKER_PD-S600_00_ROHS
TOP C1CLAMP_PD-S600_00_ROHS
FAN-RUBERCOV_PD-S600_00_ROHS
COLORW-SEN-STD_PD-S600_00_ROHS
TUNNEL-ADJ-COVER_PD-S600_00_ROHS
TOP-COVER_PD-S600_2BJ_ROHS
TOP-COVER_PD-S600_2BJ_ROHS
BOTTOM-COVER_PD-S600_4AW_ROHS
BOTTOM-COVER_PD-S600_4AW_ROHS
FRONT-COVER_PD-S600_4AW_ROHS
FRONT-COVER_PD-S600_4AW_ROHS
RIGHT-COVER_PD-S600_4AW_ROHS
RIGHT-COVER_PD-S600_4AW_ROHS
LEFT-COVER_PD-S600_4AW_ROHS
LEFT-COVER_PD-S600_4AW_ROHS
LAMP-COVER_PD-S600_4AW_ROHS
LAMP-COVER_PD-S600_4AW_ROHS
ZOOM-RING_PD-S600_0CJ_ROHS
PAINTED-ZOOM-RING_PD-S600_0CJ_ROHS
LENS-COVER_PD-S600_4AW_ROHS
LENS-COVER_PD-S600_4AW_ROHS
4-KEY_PD-S600_3AG_ROHS
2-KEY-LED-LENS_PD-S600_3AG_ROHS
IR-LENS-F_PD-S600_DEFAULT_ROHS
IR-LENS-F_PD-S600_DEFAULT_ROHS
IR-LENS-B_PD-S600_DEFAULT_ROHS
STRIP_PD-S600_4AW_ROHS
Location
JP5
CN5 CN6 CN7
CN5 CN6 CN7
CN5 CN6 CN7
CN5 CN6 CN7
J2 JP3
J2 JP3
J7
CON2
P1
JP1
CON3
71
PJ402D-2
Item
257
258
259
260
261
262
263
264
265
266
267
268
269
270
271
272
273
274
275
276
277
278
279
280
281
282
283
284
285
286
287
288
289
290
291
292
293
294
295
296
297
298
299
300
301
302
303
304
305
306
307
308
309
310
311
312
313
314
315
316
317
ViewSonic P/N
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
M-00004773
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
PL-00003113
C-00003075
N/A
M-00003102
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
318
319
320
321
322
323
324
325
326
327
328
329
330
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
B-00004678
B-00004679
Ref. P/N
P1634-4630-99
P1634-4650-0E
P1634-4650-99
P1634-4660-00
P1634-4670-00
P1634-4680-00
P1635-0010-00
P1635-0020-00
P1635-0030-00
P1635-0040-00
P1635-0070-00
P1635-0100-00
P1635-0110-00
P1635-0150-00
P1635-0170-00
P1635-0200-00
P1635-0520-00
P1635-0540-00
P1635-0570-00
P1635-4500-00
P1635-4500-99
P1635-4510-00
P1635-4510-99
P1635-6000-00
P1635-6010-00
P1635-6030-00
P1636-7010-00
P1636-7400-00
P1636-7410-00
P1636-7630-00
P1636-7640-00
P1638-0000-00
P1638-1010-00
P1638-1030-00
P1638-1040-00
P1638-1050-00
P1638-1060-00
P1638-1081-00
P1638-1090-00
P1638-1100-00
P1638-1500-00
P1638-1530-00
P1638-1540-00
P1638-1550-00
P1638-1560-00
P1638-1570-00
P1638-1630-00
P1643-0005
P1643-0008
P1643-0012
P1643-0013
P1643-0017
P1643-0021
P1646-6100
P1935-0050-00
P1935-0060-00
P1935-0080-00
P1935-0120-00
P2038-1010-00
P2235-0000-00
P2238-1010-00
P2247-8001
P2447-0001
P2447-0101
P2934-2020-00
P2934-2030-00
P3237-0500-00
P3237-0501-00
P3237-0502-00
P3237-0701-00
P3247-5000
P3247-5001
P3247-5100
P3247-5101
Description
STRIP_PD-S600_4AW_ROHS
IO-COVER_PD-S600_4AW_ROHS
IO-COVER_PD-S600_4AW_ROHS
FOOT-SCREW_PD-S600_00_ROHS
FOOT-SCREW-M6_PD-S600_00_ROHS
RUBBER-BTM-CASE_PD-S600_00_ROHS
MIRROR CLAMP_PD-S600_00_ROHS
TOPCAP SINK_PD-S600_00_ROHS
COLORW CLAMP_PD-S600_00_ROHS
C1 STOP_PD-S600_00_ROHS
COLORW-TUNNER_PD-S600_00_ROHS
HEAT SINK_PD-S600_00_ROHS
COLORW-CUTTER_PD-S600_00_ROHS
BAFFLE_PD-S600_00_ROHS
HOUSING BLOCK_PD-S600_DEFAULT_ROHS
WC-2 PIN GOOD_PD-S600_00_ROHS
SHD-PWR-BD_PD-S600_DEFAULT_ROHS
HOLDER-PLATE_PD-S600_DEFAULT_ROHS
HOLDER-PCB_PD-S600_DEFAULT_ROHS
AL-PLATE_PD-S600_DEFAULT_ROHS
AL-PLATE_PD-S600_DEFAULT_ROHS
IO-PLATE_PD-S600_DEFAULT_ROHS
IO-PLATE_PD-S600_00_ROHS
OE CHASS_PD-S600_00_ROHS
OE BOT CAP_PD-S600_00_ROHS
DMD-HSINK_PD-S600_00_ROHS
DMD-0.55INCH_PD-S600_ROHS
AC1-AR COATING_PD-S600_ROHS
AC2-AR COATING_PD-S600_ROHS
MIRROR_PD-S600_ROHS
UV-IR_PD-S600_ROHS
STRAP_PREMIER_PD-S600_ROHS
C1 PAD_PD-S600_ROHS
C2 PAD_PD-S600_ROHS
MIRROR PAD_PD-S600_ROHS
EMI PAD_PD-S600_ROHS
DMD PAD_PD-S600_ROHS
FAN-PAD-1_PD-S600_ROHS
FAN-PAD-2_PD-S600_ROHS
BUFFER-PAD_PD-S600_ROHS
MYLAR-POWER-BD_PD-S600_ROHS
MAINBOARD-MYLAR_PD-S600_ROHS
AL-SHEET-MYLAR_PD-S600_ROHS
METAL-DOME_PD-S600_ROHS
MESH_PD-S600_ROHS
SPONGE_PD-S600_ROHS
LENS-COVER-MYLAR_PD-S600_ROHS
OE TOP MODULE PD-S600
COLORWHEEL MODULE-SHINANO
FOOT ASSEMBLY_PD-S600
LAMP COVER ASSEMBLY_PD-S600
IO ASSEMBLY_PD-S600
FAN MODULE_PD-S600
DS-600 LENS ASSEMBLY
PLATE-USHIO-E19_DPD-S601_00_ROHS
CAP-NET-2_DPD-S601_00_ROHS
CAP-NET-1_DPD-S601_00_ROHS
CAP-CLAMP-USHIO_DPD-S601_00_ROHS
FAN-MYLAR_APD-S601_ROHS
SENSOR BRACKET_TPD-S601_ROHS_3CS
REFLECTIVE TAPE_TPDS601_ROHS
POWER_216W_TPD-S601 P10-TPDS601_DOMINION_ASY_ROHS
MB_SMT_PCB_ASY_APD-S601_ROHS
MB_DIP_PCB_ASY_APD-S601_ROHS
LAMP BASE_MPD-S601_00_ROHS
LAMP CLAMP-PPS_MPD-S601_00_ROHS
FIR_PCB_2L_FR4_T:1.6MM_REV:A_PD-S610_ROHS
BIR_PCB_2L_FR4_T:1.6MM_REV:A_PD-S610_ROHS
CW-SENSOR_PCB_2L_FR4_T:1.6MM_REV:A_PD-S610_ROHS
KEYPAD_PCB_2L_FR4_T=1.6MM_REV=A_PD-S610_ROHS
FIR_SMT_PCB_ASY_PD-S610_ROHS
BIR_SMT_PCB_ASY_PD-S610_ROHS
FIR_DIP_PCB_ASY_PD-S610_ROHS
BIR_DIP_PCB_ASY_PD-S610_ROHS
Location
72
PJ402D-2
Item
331
332
333
334
335
336
337
338
339
340
341
342
ViewSonic P/N
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
B-00004680
N/A
N/A
N/A
Ref. P/N
P3247-7001
P3335-0050-00
P3437-0600-00
P3438-1510-00
P3443-1000
P3447-6000
P3634-4640-00
P3634-4640-99
P3634-7400-00
P3635-0560-00
P3636-7110-00
P3637-0000-00
343
344
345
346
347
348
349
350
351
352
353
354
355
356
357
358
359
360
361
362
363
364
365
366
367
368
369
370
371
372
373
374
375
376
377
378
379
380
381
382
383
384
385
386
387
388
389
390
391
392
393
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
P-00004844
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
394
N/A
P1600-RC02
395
396
397
398
399
400
401
402
403
404
405
406
407
408
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
04739-0050-00
P1600-BM02-00
82143-4000-00
01635-1490-00
83034-0000-00
83034-001*2CF
83034-0030-00
83034-420-99
83034-420*00
83034-440-0AT
83034-440*00
83034-460-0AT
83034-460*00
83035-3000-00
P3647-9001
P3834-2050-00
P4100-100
P4100-BO
P4143-1001
P4143-1002
P4143-1003
P4143-1004
P4143-1007
P4143-1014
04039-R128-00
04039-R157-00
04039-R544-00
04238-R765-00
04238-R766-00
04238-R801-00
P1238-504-VIE
P1638-5007-00
P1638-5008-00
P1638-5010-00
P1638-5011-00
P1638-R501-01
P1638-R502-00
P1639-R306-00
P1639-R481-00
P1639-R690-00
P4138-5002-00
P4138-5003-00
P4138-5004-00
P4138-5005-00
P4139-4002-00
P4139-4003-00
P4139-6002-00
P4139-6003-00
P4139-6004-00
P4139-A002-00
P4139-A003-00
P4139-A004-00
-P4183-6002-00
-P4183-6003-00
-P4183-6004-00
02547-1006-00
02547-1007-00
02547-100A-00
02547-100G-00
02547-100H-00
02547-1027-00
02547-102A-00
02547-B060-00
02547-B063-00
04039-184-00
Description
KEYPAD_SMT_PCB_ASY_PD-S610_ROHS
TUNNEL CLAMP L_MPD-X601_00_ROHS
DMD_PCB_8L_FR4_T:1.6MM_REV:A_PD-X600_ROHS
BALLAST MYLAR_PD-X600_DEFAULT_ROHS
TOP_ASY_PD-X600_ROHS
DMD_SMT_PCB_ASY_PD-X600_ROHS
FOOT-BUTTON_APD-X601_0CI/C0463_ROHS
FOOT-BUTTON_APD-X601_0CI/C0463_ROHS
THERMAL PAD TFLEX-640_APD-X601_00_ROHS
DMD SHD_PD-S600_3M_ROHS
LAMP E19-USHIO-205W-ASAHI_APD-X601_ROHS
MB_PCB_8L_FR4_T:1.6MM_REV:A_APD-X601_ROHS
USHIO-205W-BALLAST_ASY_APD-X601_ROHS -E19- 205WtBALLAST_ASY_APD-X601_ROHS
LAMP CAP-450G903_MPD-X611_0A_ROHS
PD-S611_DLP_SVGA_BODY_1
PD-S611_DLP_SVGA_BODY
BOTTOM_ASY_PD-S611_ROHS
OPTICAL ENGINE_ASY_PD-S611_ROHS
BALLAST_ASY_PD-S611_ROHS
POWER_ASY_PD-S611_ROHS
ENGINE BODY_ASY_PD-S611_ROHS
USHIO LAMP MODULE_ASY_PD-S611_ROHS
PKG_VIEWSONIC_VIEWSONIC_PJ402D-2_KIT_USA
CD ROM_VIEWSONIC_PJ402D-2_USA
LB_NO BRAND_NO MODEL_FOR HI POT PASS
LB_NO BRAND_NO MODEL_FOR OK CERTIFICATION
CARTON PAD_NO BRAND_NO MODEL-P1639-690
LB_NO BRAND_04238-765
SILICA GEL DESICCANT_NO BRAND_50G-04039-128
CARTON LB_VIEWSONIC_PJ402D-2_76.2MM*76.2MM
LABEL BIRD LOGO PJ-X711 VIEWSONIC
QG_VIEWSONIC_PJ402D-2_GLOBAL
WARNING LB_VIEWSONIC_PJ402D_FOR MERCURY
LB_NO BRAND_NO MODEL_FOR BATTERY RECYCLE
OUTER CARTON_VIEWSONIC_PJ402D+_CHINA
CD ROM_VIEWSONIC_PJ402D+_CHINA
CARTON LB_VIEWSONIC_PJ402D-2_76.2MM*76.2MM
FCC LB_VIEWSONIC_PJ402D+_CHINA
LB_NO BRAND_NO MODEL_FOR HI POT PASS
POUCH_VIEWSONIC_PJ402D_BLACK-P1639-306-VIE
WY_VIEWSONIC_PJ402D_P1639-481-VIE
LB_NO BRAND_NO MODEL_WARNING-P1638-502
LB_NO BRAND_NO MODEL_WARNING-P1638-501A
DLP_SVGA_PD-S600-04039-544_ROHS
LB_NO BRAND_32*13MM-04238-801-ROHS
HDPE BAG_NO BRAND_04039-157
SILICA GEL DESICCANT_NO BRAND_50G-04039-128
D-SUB CABLE,L=1.8M TTL,FOR PJ-X900
S-VIDEO CABLE,L=1.8M TTL,FOR PJ-X900
POWER CORD US L=1.8M,TTL,FOR PJ-X900
POWER CORD (EUR) #B TTL,1.8M,PJ-X000
POWER CORE (ENG) TTL,1.8M,
POWER CORD (AUS),1.8M #B YUNG-LI,PJ-X900
YP03-YC12,YUNG-LI #B POWER CORD,CHINA
RCA/Y TO RCA/Y,BLK,2M CABLE,LIN SHIUNG
3.5ST,PHONE PLUG-2RCA 2M,BLK,CABLE,LIN SHIUNG
PE BAG 298x190mm
VIEWSONIC_VIEWSONIC PJ-46D_REMOTE
CONTROL PD-S600 W/B AAA 2PCS
ALKALINE BATTERY-AAA_MX2400_DURACELL_NOT
CHARGE 1.5V LEAD
PREMOTE CONTROL _PD-S600-BM02
REMOTE CONTROLLER ASY#A
S:1.7*4*A0.5 BL HK*LED COVER
HK*BUTTON 17 COLOR HK*HOLDER
HK*FRONT COVER
HK*FRONT COVER COLOR HK*BACK COVERR
HK*BACK COVER
HK*BATTERY COVER
HK*BATTERY COVER COLOR HK*BATTERY SPRING(ANODE) HK
Location
73
PJ402D-2
Item
409
410
411
412
413
414
415
416
417
418
419
420
421
422
423
424
425
426
427
428
ViewSonic P/N
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Ref. P/N
83035-3010-00
83035-3020-00
83047-5100--00
83047-3000-00
02037-2200-00
02037-BA70-00
02137-8370-00
02237-2GR0-00
02437-D400-00
83037-5000-00
02011-0044-00
02153-0104-00
02037-C920-00
02037-D400-00
02237-0280-00
02437-F910-00
18938-9120-00
18983-6018-00
82138-360-00
83038-5020-00
Description
BATTERY SPRING(MINUS)HK*BATTERY SPRING(MINUS)HK*REMOTE ELECTROM,DIP,ASY
REMOTE ELECTROM,SMT,ASY
RLS4148N #LL-34 IP*A DIODE 7EE162>A
PT2221#SOP-20 INFRARED TR.PTC
R,1,5%,1/16W,0603 HK*- RESISTOR
C,200PJ/50V,NP0,0603_T0.9MM C-CAP
SW,SOP-112HST MITSUMI
REMOTE PCB,1 LAYER PCBC
TR NPN_SST3_SST2222AT116_ROHM_ROHS
SIR-563ST3F INFRARED DIODES,ROHM
LASER,B.6@SIZE,EL-501 LASER,E-LASER ENTERPISE
100UF/6.3V 5D*7L HK*- ELECTROLYTIC CAPACITOR
OSC,CRCR-455KHZ,0.2% ZTB,CVIC-DAWN
AW_VIEWSONIC_VIEWSONIC_PJ402D_PMS423C_USA
PKG_VIEWSONIC_VIEWSONIC_PJ402D_KIT_USA
N/P_VIEWSONIC_PJ402D
LB,NB_LASER_NOTICE TS*-
Location
74
PJ402D-2
Chapter 10
Appendix
How to reset the lamp hours of PJ402D-2:
1. Enter the engineering mode.
(1) Press “Menu” button to open the OSD menu.
(2) Move the color bar to “Advanced” item.
(3) Move down the color bar to “Auto Source Select” item
.
(4) Press the direction keypad following the actions below:
Right once, left twice, right three times, left four times
2. Move the color bar to “Lamp Total Hours”.
3. Press “Menu” button.
4. Then the lamp hours would be reset to zero.
75
PJ402D-2
* Reader’s Response*
Dear Readers:
Thank you in advance for your feedback on our Service Manual, which allows continuous improvement
of our products. We would appreciate your completion of the Assessment Matrix below, for return to
ViewSonic Corporation.
Assessment
A. What do you think about the content of this Service Manual?
Unit
Excellent
Good
Fair
Bad
Excellent
Good
Fair
Bad
1.Precautions and Safety Notices
2.System Introduction
3.Firmware Update
4.Machine Dissassembly and
Replacement
5.Trouble shooting
6.Connector Information
7.FRU(Field Replaceable Unit) List
8.Basic Circuit Diagrams
9.Recommended Spare Parts List
10. Appendix
B. Are you satisfied with this Service Manual?
Item
1. Service Manual Content
2. Service Manual Layout
3. The form and listing
C. Do you have any other opinions or suggestions regarding this service manual?
Reader’s basic dada:
Name:
Title:
Company:
Add:
Tel:
Fax:
E-mail:
After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile
1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes
([email protected])
76
PJ402D-2

Service Manual - Michael Jay Lissner

Transcription

Similar documents

inductors / beads

+81-48-541

Service Manual - Michael Jay Lissner