Polaris RZR 1000 Application Support Guide

Transcription

Polaris RZR 1000 Application Support Guide
Variants Confirmed
Supported Engine
Supported ECU’s
Parts Required
Optional Accessories
O.E.M. Options supported
O.E.M. Options not supported
Basemap Available
Firmware version
Specialty Tools required
Release Date
Currently Supported Dash’s
Installation Type
OEM ECU
Difficulty Level
29/07/15
Rev.1.
Polaris RZR1000 XP 2011>> Onwards
110hp Two cylinder, 1000cc engine
Elite 1500 & Elite 2500
(HT-150901) Elite 1500 Short loom Kit
(HT-020002) Haltech Dual Channel Ignitor
(HT-059976) Haltech Wideband Kit
(HT-060100) HALTECH IQ3 Display Dash (HT-060100)
(HT-060101) HALTECH IQ3 2Gb GPS/G-meter Logger Dash
Racepak Dash Kit http://utvracepak.com/ with Haltech V2 interface module.
Speedometer
RPM
Coolant Temp
Demand Drive AWD (4x4 Switch) Indicator Light and actuation request
Gear Position
Check Engine Light (Haltech ECU Only)
High Beam warning light
Fuel Level
Trip Meter
Odometer
Electric Power Steering
Rear Diff Lock (Turf Mode) Indicator Light on Dash and Solenoid actuation
request
Yes - Downloads Page http://www.haltech.com/downloads-2/basemaps/
2.06 - Release onwards
Haltech Support Guide
Wire Cutters/ strippers
Soldering Iron
Heat Shrink
Electrical tape
Laptop compatible with Haltech ESP Software (2.05)
1st August, 2015
-2014 RZR1000 XP
Full OEM ECU Replacement wired in over the top of the OEM ECU loom
Must Be Removed
Advanced
Haltech Engine Management Systems | 3 Centre Pl, Wetherill Park, NSW Australia 2164
Haltech USA | 707 Downs Ave, Suite 140, Lexington KY 40505
ELITE 1500 ECU CONNECTOR (34 PIN)
DPO 2
1
AVI 4
2
IGN OUT 1
3
IGN OUT 2
4
POLARIS ECU CONNECTOR
V/BR
O/B
O/Y
DL/W
Y/B
2
Y/R
7
HALTECH DUAL CHANNEL IGNITER
# HT-020002
W
1
100
41
THERMOFAN RELAY CONTROL
100
21
PEDAL POSITION SENSOR #1
200
56
IGNITION OUTPUT 1 (MAG)
200
54
IGNITION OUTPUT 2 (PTO)
200
10
+5V PEDAL SUPPLY 1
200
23
+5V SENSOR SUPPLY (MAP)
100
25
+5V PEDAL SUPPLY 2
100
37
+5V SUPPLY TPS 1
100
53
GROUND FROM CHASSIS
100
54
GROUND FROM CHASSIS
200
47
GROUND FROM CHASSIS (IGNITOR)
200
50
GROUND FROM CHASSIS (IGNITOR)
100
16
IGNITION INPUT +12V SWITCHED
100
23
TRANSMISSION GEAR INPUT
200
19
MANIFOLD PRESSURE SENSOR
100
12
FUEL LEVEL SENSOR
200
20
THROTTLE POSITION SENSOR 2
B
6
4
5V
9
O
O/BR
O
O/R
O/B
GND
10
GND
11
B
BR
B
BR
BR
BR
IGN INPUT
AVI 10 (TPS)
AVI 9 (MAP)
AVI 2
13
14
15
16
P
O
W
W
Y
Y
O/B
V/W
O/R
DG/BR
AVI 3
17
INJ 1
19
L
V
200
44
INJECTOR 1
INJ 2
20
L/B
DG
200
43
INJECTOR 2
DPO 3
23
V/R
BR/W
200
46
AWD CONTROL OUTPUT
DPO 5 (FUEL PUMP)
24
B/Y
DG/Y
100
42
FUEL PUMP RELAY
DPO 6 (ECR)
25
B/R
DG/Y
100
15
EFI RELAY CONTROL
R/L
R/DL
100
56
12V FROM EFI RELAY
HC+12V
26
Looking into ECU Connector
1
9
10
17
18
25
26
34
100
LEGEND - WIRE COLOUR:
B = BLACK
O = ORANGE
BR = BROWN
P = PINK
DL = DARK BLUE
G = GREEN
R = RED
LG= LIGHT GREEN
V = VIOLET
GY = GREY
200
L = BLUE
Y = YELLOW
DG = DARK GREEN
WHEN TWO COLOURS ARE USED IN A WIRE BY THE ALPHABETICAL CODE,
THE FIRST LETTER INDICATES THE BASIC WIRE COLOUR,
THE SECOND COLOUR INDICATES THE COLOUR OF THE STRIPE.
ELITE 1500 - POLARIS RZR 1000 2014
HALTECH, SYDNEY AUSTRALIA
DATE: 28TH APRIL 2015
REV A
SHEET 1 OF 2
TRIGGER
1
AIR TEMP
3
COOLANT
4
TRIGGER -
5
SPI 1
8
SPI 2
9
12V
11
AVI6
AVI 1
GND
GND
GND
12
13
14
15
16
POLARIS ECU CONNECTOR
Y
W
GY
DL
V
Y
G
B
GY
GY
GY/B
G/R
R/W
R/DL
GY/O
O
GY/Y
DG
B/W
V/W
B/W
V/B
B/W
V
V/P
V
DPO 4
19
AVIP 5
20
CAN H
23
CAN L
DBW 1 / DPO
DBW 2 / DPO
24
25
26
V/O
GY
O/G
DL/B
W
Y
L
DG
BR/B
B/G
BR/R
G/B
200
13
CRANKSHAFT SENSOR + (REL)
200
27
AIR TEMPERATURE SENSOR
200
15
COOLANT TEMPERATURE SENSOR
200
01
CRANKSHAFT SENSOR - (REL)
100
20
AWD REQUEST INPUT
200
32
VEHICLE SPEED SENSOR INPUT
100
55
+12V FROM EFI RELAY
100
35
BRAKE PEDAL SWITCH (MUST BE ON AVI INPUT)
200
03
THROTTLE POSITION SENSOR 1
200
04
SENSOR GROUND
100
03
SENSOR GROUND (PPS2)
100
04
SENSOR GROUND (MAP)
100
05
SENSOR GROUND (TPS)
100
06
SENSOR GROUND (PPS1)
100
40
CHASSIS RELAY CONTROL
100
11
PEDAL POSITION SENSOR #2
100
32
CAN HIGH - VEHICLE BUS
100
44
CAN LOW - VEHICLE BUS
200
52
DBW MOTOR -
200
51
DBW MOTOR +
Looking into ECU Connector
1
7
8
13
14
19
20
26
100
200
LEGEND - WIRE COLOUR:
B = BLACK
BR = BROWN
G = GREEN
LG= LIGHT GREEN
O = ORANGE P = PINK R = RED V = VIOLET
DL = DARK BLUE DG = DARK GREEN
Y = YELLOW
WHEN TWO COLOURS ARE USED IN A WIRE BY THE ALPHABETICAL CODE,
THE FIRST LETTER INDICATES THE BASIC WIRE COLOUR,
THE SECOND COLOUR INDICATES THE COLOUR OF THE STRIPE.
GY = GREY
L = BLUE
ELITE 1500 - POLARIS RZR 1000 2014
HALTECH, SYDNEY AUSTRALIA
DATE: 28TH APRIL 2015
REV A
SHEET 2 OF 2

Polaris RZR 1000 Application Support Guide

Transcription

Similar documents