service manual - Audio Lab of Ga

XM-2150GSX
SERVICE MANUAL
US Model
Canadian Model
Ver 1.0 2001. 12
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
150 watts per channel minimum continuous average power into
4 ohms, both channels driven from 20 Hz to 20 kHz with no more
than 0.04% total harmonic distortion per Car Audio Ad Hoc
Committee standards.
Other Specifications
Circuit system
OTL (output transformerless) circuit
Pulse power supply
Inputs
RCA pin jacks
High level input connector
Outputs
Speaker terminals
Through out pin jacks
Speaker impedance
2 – 8 Ω (stereo)
4 – 8 Ω (when used as a bridging amplifier)
Maximum outputs
300 W × 2 (at 4 Ω)
760 W (monaural) at 4 Ω
Rated outputs (supply voltage at 14.4 V)
150 W × 2 (20 Hz – 20 kHz, 0.04% THD,
at 4 Ω)
190 W × 2 (20 Hz – 20 kHz, 0.1% THD,
at 2 Ω)
380 W (monaural) (20 Hz – 20 kHz, 0.1% THD,
at 4 Ω)
Frequency response
5 Hz – 100 kHz ( +0.5
–3 dB)
Harmonic distortion
0.005% or less (at 1 kHz, 4 Ω)
Input level adjustment range
0.2 – 6.0 V (RCA pin jacks)
0.4 – 12.0 V (High level input)
High-pass filter
Low-pass filter
Low boost
Power supply voltage
Current drain
Dimensions
Mass
Supplied accessories
50 – 300 Hz, –12 dB/oct
50 – 300 Hz, –12 dB/oct
0 – 10 dB (40 Hz)
10.5 – 16 V
at rated output : 40 A (at 4 Ω)
Remote input : 2 mA
Approx. 14 1/8 × 2 1/4 × 10 1/2 in.
(358 × 50 × 264 mm)
(w/h/d) not incl. projecting parts and controls
Approx. 3.5 kg (7 lb. 11 oz.) not incl. accessories
Mounting screws (4)
Design and specifications are subject to change without
notice.
STEREO POWER AMPLIFIER
9-873-436-01
Sony Corporation
2001L0400-1
© 2001.12
e Vehicle Company
Published by Sony Engineering Corporation
1
XM-2150GSX
Note for Replacement of FET
Change the both channels of FETs at the output stage.
If one or both parts in the following combination is broken, the
service kit should be ordered.
Service kit part No.
Q108, 112
X-3381-586-1
Q208, 212
Q109, 113
X-3381-587-1
Q209, 213
TABLE OF CONTENTS
1. GENERAL
Location and Function of Controls .......................................... 3
Connections ............................................................................. 3
2. DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
Bottom Plate ........................................................................ 6
Main Board ......................................................................... 6
Front Panel .......................................................................... 7
Led Board ............................................................................ 7
3. ELECTRICAL ADJUSTMENT ...................................... 8
4. DIAGRAMS
4-1.
4-2.
4-3.
4-4.
Block Diagram .................................................................... 9
Schematic Diagram –Main Section (1/2)– ........................ 10
Schematic Diagram –Main Section (2/2)– ........................ 11
Printed Wiring Boards –Main Section– ............................ 12
5. EXPLODED VIEWS
5-1. Heat Sink Section .............................................................. 14
5-2. Main Board Section .......................................................... 15
6. ELECTRICAL PARTS LIST ........................................ 16
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
XM-2150GSX
SECTION 1
GENERAL
This section is extracted
from instruction manual.
3
XM-2150GSX
4
XM-2150GSX
5
XM-2150GSX
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. BOTTOM PLATE
3 BTP 3x6
2 BTP 3x6
1 BTP 3x6
4 P 2.6x2.8
5 bottom plate
7 insulating sheet
6
2-2. MAIN BOARD
3 B.TT. 3x14
4 B.TT. 3x14
5 B.TT. 3x14
2 BTP 3x6
7 MAIN board section
1 BTP 3x6
8 CN808
6
6
XM-2150GSX
2-3. FRONT PANEL
4 MAIN board
2 P 3x8
3 front panel (2ch)
1 P 3x8
2-4. LED BOARD
1 BTP 3x6
2 LED board
heat sink (main)
7
XM-2150GSX
SECTION 3
ELECTRICAL ADJUSTMENT
Bias Adjustment
Note : In Bias Adjustment, adjust RV105 if any of Q108 through
Q113 are replaced. Adjust RV205 if any of Q208 through
Q213 are replaced.
Condition : This adjustment should be performed about one minute
after the remote mode is turned on at a room temperature of about 25°C.
Setting :
B+,REM terminal
set
+
–
Stabilized
Power suppy
GND terminal
Procedure :
1. Turn the variable resistors RV105 (L-CH) and RV205 (R-CH)
full clockwise as seen from the component side to minimize the
bias current.
2. The input signal is to be no signal.
3. Apply the voltage to the B+ and REM terminals from the stabilized power supply and gradually increase it up to 14.4 V while
checking for any unusual current.
4. For the XM-1502SX, adjust each of RV105 (L-CH) and RV205
(R-CH) so that the power current of the stabilized power supply
is increased in steps of 500 mA (total of 1 A). For the XM1902GX, adjust each of RV105 (L-CH) and RV205 (R-CH) so
that the power current is increased in steps of 600 mA (total of
1.2 A).
5. After adjustment, check that the power current is at 1.3 to 2.0 A.
Adjustment Location : Main board (component side)
– MAIN BOARD (COMPONENT SIDE) –
RV105
BIAS ADJUSTMENT
8
RV205
BIAS ADJUSTMENT
XM-2150GSX
SECTION 4
DIAGRAMS
4-1. BLOCK DIAGRAM
PRE AMP
IC101(1/2)
CNJ801-1,-3
-1
INPUT
PRE AMP
IC101(2/2)
L.P.F
IC102(1/2)
L.P.F
IC103(2/2)
LOW BOOST
IC104(2/2)
OFF
3
2
L
H.P.F
IC102(2/2)
S801-1
FILTER
LPF
6
5
1
7
5
7
2
1
RV801-1
FILTER
OUTPUT
(THROUGH) -3
6
7
5
6
RV801-2
FILTER
7
CNJ803
3
2
LINE
SWITCH
Q102
DIFFERENTIAL
AMP
Q103
1
+14.2V
(B+)
L
HI LEVEL
INPUT
PRE AMP
IC201(1/2)
CNJ801-2,-4
-4
OUTPUT
(THROUGH)
2
3
PRE AMP
IC201(2/2)
6
5
1
L.P.F
IC202(1/2)
H.P.F
IC202(2/2)
7
5
7
2
RV801-3
FILTER
R
-2
L.P.F
IC103(1/2)
1
2
5
6
S801-2
FILTER
LPF
TEST TONE
GENERATOR
IC301
S301
TEST TONE
HPF
5
D302
1
7
3
2
LINE
SWITCH
Q202
1
DRIVE
AMP
Q106
POWER
AMP
Q109,113
DIFFERENTIAL
AMP
Q203
DRIVE
AMP
Q205
POWER
AMP
Q208,212
+14.2V
(B+)
RV205
BIAS
2
+14.2V
(B+)
–14.2V
(B–)
LEVEL
SHIFT
RV103-2 Q201
LOW
BOOST
(40Hz) –14.2V
(B–)
BIAS
Q207
RV104-2
LEVEL
DIFFERENTIAL
AMP
Q204
LINE SWITCH
CONTROL
Q801,802
2
SPEAKER
OUT
L
OVER CURRENT
DET
Q114,116
DIFFERENTIAL
AMP
Q104
OFF
D301
7
LINE AMP
IC204(2/2)
1
CN804
1
POWER
AMP
Q108,112
BIAS
Q107
RV104-1
LEVEL
LOW BOOST
IC204(1/2)
RV801-4
FILTER
DRIVE
AMP
Q105
RV105
BIAS
LEVEL
SHIFT
RV103-1 Q101
LOW
BOOST
(40Hz) –14.2V
(B–)
R
INPUT
LINE AMP
IC104(1/2)
HPF
CN805
1
2
SPEAKER
OUT
R
OVER CURRENT
DET
Q214,216
DRIVE
AMP
Q206
POWER
AMP
Q209,213
DC OFFSET
DET
Q803-805
REM
CN802
1
POWER
ON/OFF
Q903
DC-DC CONVERTER
IC901
DC DET
IC902
CN801
+12V 2
GND
DC-DC
CONVERTER
TRANSFORMER
T901
RECT
D909
D921
F901
B+
SWITCH
Q901,902
1
11
12
INVERTER
Q904,905
10
LED DRIVE
Q813
REF.
REG
PROTECT LATCH
Q812
+14.2V
(B+)
D808
POWER
D810
OFFSET
Q808
D811
THERMAL
D808
D807
INVERTER
Q906,907
9
DRIVER
Q909
1
2
TEMP.DET
TH801-803,
806-809,
812,813
+51V
(B+)
RECT
D907
+53V
(B+)
+20.3V
(B+)
RECT
D911,917
B+
REG
Q910
+14.2V
(B+)
RECT
D912,918
B–
REG
Q911
–14.2V
(B–)
8
PROTECT LATCH
Q810
LED DRIVE
Q809
D919
RECT
D905
DRIVER
Q908
14
LED DRIVE
Q811
+14.2V
(B+)
D809
OVER
CURRENT
+53V
(B+)
RECT
D906
–51V
(B–)
RECT
D908
–51V
(B–)
D920
RECT
D910
15
16
HI-CURRENT
/HI-VOLTAGE
DET
IC903,Q912
3
4
9
9
+20.3V
(B+)
–20.3V
(B–)
• Signal path
: AUDIO
D922
–53V
(B–)
–20.3V
(B–)
XM-2150GSX
4-2. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 13 for IC Block Diagram. • Refer to page 13 for Waveform.
C113
C106
R103
C103
R106
IC103
R116
R104
R313
R119
R118
C109
C108
C115
IC102
C104
R105
RV801
IC102
R154
C105
R117
RV801
R111
R102
C102
C131
R115
R120
C221 C231
C114
C110
R109
R219
R218
R254
C112
C111
IC101
C130
R101
R220
IC101
C101
R113
R114
R110
R112
R107
C107
CN803
C902
C207
R206
C901
R205
C208
R207
C204
C213
R214
R210
R204
R213
C212
C211
C214
C210
C201
C230
R202
R209
R215
R211
R217
RV801
IC201
R201
C202
C215
IC202
IC103
R216
C209
C203
R314
RV801
IC202
IC201
C222
C206
R203
C205
R212
R307
IC301
R301
S301
(Page 11)
IC301
R311
R934
R312
CN802
R926
R308
C303
R303
C914
R302
Q912
C305
C915
CN801
F901
R929
R925
R309
L901
C301
R310
C302
R304
D301
R315
R305
R306
D302
R927
C304
D915
IC903
IC B/D
R824
R827
R823
D826
TH806
D825
TH803
D824
TH802
D821
TH801
D820
JR104
D805
R828
R852
R847
R846
R845
R844
R841
R840
R838
R830
C810
R839
R905
R820
R821
R904
C809
R903
Q812
R826
D827
TH807
IC901
R851
C807
R819
D830
TH808
C909
Q810
D811
Q809
TH809
D807
R817
TH812
D831
R829
R825
D803
R814
D810
D809
D808
R812
R813
TH813
C950
C806
R818
R901
Q813
CN806
R822
C808
Q811
CN807
C911
Q808
R850
C805
PL801
10
10
R902
XM-2150GSX
4-3. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) —
R135
R131
D919
C124
Q105
D101
R156
R165
D102
R167
R141
R133
Q112
Q108
RV105
Q114
IC104
Q116
R140
IC104
C119
C123
Q102
C127
R136
R145
R158
R143
Q103
R149
R150
CN804
R155
R144
R146
Q104
R123
C117
C118
R121
R137
R157
C904
R152
R160
C906
Q113
R142
C126
R130
C128
C905
Q109
RV104
R151
R139
R129
C120
Q101
R134
Q107
C116
R159
R168
C903
R153
D104
D103
RV103
Q106
R124
R125
R122
R126
R127
R128
D920
R132
R138
C133
D921
C224
R235
R231
R256
Q205
D201
R265
D202
Q208
RV205
Q216
Q214
R233
IC204
R267
Q212
R241
IC204
R239
C219
C223
Q202
C227
R236
Q203
R245
R243
R249
R258
R253
R250
CN805
R255
R244
R246
Q207
C216
Q204
R257
C228
R251
R240
R252
R237
R223
C220
Q201
C217
Q209
R229
C218
R221
R259
R234
RV104
R230
Q206
R224
R225
R222
R268
D204
D203
R227
RV103
R242
C226
Q213
R228
R226
R232
R238
D922
C233
(Page 10)
Q910
D909
Q801
R809
R801
R923
C932
D911
C936
R803
Q805
R802
D801
R808
D913
D917
C938
C934
Q804
Q802
D912
R804
D914
C935
C937
C939
R807
C801
R805
C803
Q803
D802
R806
R810
D918
Q911
C933
D910
R924
C802
Q904
R915
R930
R931
Q901
T901
R916
D905
R918
C942
Q905
R921
Q908
R909
R913
Q902
C920
C922
C924
C921
C923
C925
C941
D906
C919
R942
C944
L902
R912
C917
D901
R911
Q903
R928
C912
D902
C943
D907
R943
R914
Q909
R908
R906
C940
C918
R907
IC902
R932
R933
R917
R919
C926
C928
C930
C927
C929
C931
R922
Q906
Q907
D908
C916
R920
C913
R811
R910
11
11
C804
R260
CN805
C228
RV104
R222
RV103
CNJ801
12
CN803
12
S301
JW101
C915
CN802
CN801
L901
JW222
JW220
C917
JW100
JW149
Q903
RV801
CN804
JR221
D920
JR210
R159
JR214
JR233
JR235
R137
D820
Q114
D821
R158
R165
JR206
JR207
R156
JW255
JR213
TH802
JW153
R151
C942
JR228
R141
JR205
C809
D824
IC902
R150
TH803
C903 C904
JR234
JR113
JW152
PL801
R153
R828
R830
R850
JR100
R905
R942
R918
R913
R915
R824
C806
JW121
JR106
R826
C807
D807
R823 R822
R825
R821
JW117
D805
R820
JR101 C810 R838 JR104
JW116
D803
R839
JW118
C950
R902
C909
R903
R904
JW115
JW114
R916
R931
R932
R930
R933
R914
R917
R919
R943
R922
JW252
R920
R921
Q811
JR236
C127
JR110
JW184
R168
JW148
TH806
R827
C808 R829
JW119
JW120
R901
C912
Q813
JR112
Q902
Q108
R145
JW124
JW123
C930
JW122
C928
C926
IC901
TH807
JW111
Q109
R146
C931
C929
JW130
R139
R140
JW144
C927
JW139
JW138
C911
R167
Q112
Q901
R149
JW147
JR109
D919
JW146
C133
R138
R132
C126
R134
JW140
JW141
JW135
JW113
Q107
JW102
R135
C124
Q105 Q106
D104
D103
JW142
JW134
JW133
TH801
JW136
JW150
JW103
R909
R131
D102
D101
JW189
R133
Q801
Q113
C918
R157
C919
Q103
D902
R907
JW106
R912
JW104
Q104
R910
D901
IC101
R906
JW105
C123
R144
JW129
R143
JW126
JW143
JW164
JW131
JW127
JW132
JW128
R130
JW109
JW163
R811
C804
R802
JW125
C916
JW107
JW204
L902
R908
R304
C901
JW216
D301
IC301
R310
R301
R302
C302
JW202
JW192
D907
JR102
JW256
JR105
Q809
C805
JW218
JW110
JW254
JW253
IC903
R152
JW217
C301
R803
R805
R804
JW112
R160
JW219
R307
R312 C304 C902
JW208
JW203
Q802
R305 R303
JW200
C801
D801
D802
JW137
C128
JW221
JW201
JW197
C932
Q904
R928
C131
JW199
JW198
R129
R801
JW182
JW154
Q912
R311 R308 R309
JW207
JW215
C109
JR128
R110
D911
D917
D912
JW249
Q905
D908
C914
R314
Q908
C303
C230 R206
R315
R106
C103
R101 R103
R306
JR124
R109
JR129
Q102
C209
JW223
JR123
R313
R107
JR122
JW206
JW205
JW196
C305
IC201
R209 R210
JR125
JR127
R104 JR126
R111
JR130
C938
D302
JR121
R116
JW187
R203
R202 R201 C203
JR120
JR119
R207
R102 C130
C108
C107
C207
C204
R115
C104
Q909
R911
C913
JW225
R154
C102
JW211
R113
JW190
C936
C105
JW224
C208
IC202
JW212
JW209
C222
C210
JW227
R204
JW210
JR148
JW228
R105
JW226
C111
JW213
JW229
C106
JW236
R120
Q907
C205
S801
R205
C213
R112
D918
JW183
JR265
JW234
JW235
C101
JW232
JR135
JW185
C202
C212
R114
C110
JW250
JW157
JW158
JW159
JW160
R929
Q906
C206
C214
JR134
C933
C221
JW233
IC103
R211
JR131
R216
JW214
JW237
IC102
D910
C201
C112
C231
C114
R213
C113
JW231
D909
R212
C117
R117
JW230
C223
JR136
JW186
R214
C939
C211
JW238
JW239
JW251
JW161
JW162
C920
R925 R926
D915
R934
R927
D906
R215
JW165
R254
Q202
R229
JW195
JW194
R230
R244
JW166
C115
JW241
R243
JW188
D203
C921
JW191
JW193
JW156
R217
Q101
R118
JW242
C226
R234
D204
JW167
C922
R923
D913
D914
R924
R807
JW155
JR132
R119
R233
Q204
JW240
C118
D201
D921
C923
R809
C803
R806 R810
D905
JR133
JR139
C215
C217
JR144
R232
R238
C233
D922
C937
JR137
C218
R125
JR145
D202 Q205
Q203
R122
R225
R231
C116
R155
R121
RV205
R224
JR140 JW245 R127
JW244 JR146
Q201
R126
JW243
R124
C224
Q206
JW168
R226
JR141
R123
R235
JW173
JR138
R220
R227
IC204
JR142
C119
JR260
C220
IC104
JW247
JR147
R223
JW246
C216
R255
C120
R221 JR149
JR143
C924
C934
R219
JW180
JW248
R128
JW177
C219
JW172
C925
JW169
JW170
R241
R808
Q910
R218
JW181
JW171
R245
Q208
C802
C935
JW179
JW178
R239
R240
R246
JW174
R242 R258
R253
Q803 Q804
R228
JW176
R249
JW175
Q209
JR237
Q911
R252
Q216
R257
R267
JR243
R251
R250
JR261
JR262
Q212
JR246
Q207
JR114
TH808
D826
JR238
Q213
R259
Q214
R265
R846
TH813
JR115
JR241
JR242
TH809
D827
R847
JR118 JR117
JR251
JR240
R236
JR254
Q805
R260
JR264
C940
TH812
R256
C944 C943
D831
R852
JR259
C941
C227
R851 R268
R237
D830
JR204
JR201
Q810
C906 C905
JR209
R841
JR212
R142
JR107
JW145
RV105
JR224
Q116
R844
JR232
R136
JR111
R845
D825
JW151
R817
Q808
JR200
XM-2150GSX
4-4. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 13 for Semiconductor Location.
CN806
D811
JR203
R814
CN807
D810
Q812
R813
D809
R840
R812
R818
D808
XM-2150GSX
• Semiconductor Location (MAIN BOARD)
Ref. No.
D101
D102
D103
D104
D201
D202
D203
D204
D301
D302
D801
D802
D803
D805
D807
D820
D821
D824
D825
D826
D827
D830
D831
D901
D902
D905
D906
D907
D908
D909
D910
D911
D912
D913
D914
D915
D917
D918
D919
D920
D921
D922
Location
E-9
E-9
E-9
E-9
E-4
E-3
E-4
E-4
F-8
G-7
D-7
D-7
B-11
A-11
B-11
C-12
D-12
F-12
G-12
C-1
D-1
F-1
G-1
G-10
G-10
A-4
A-4
A-9
A-8
D-5
D-5
D-6
D-5
B-2
B-2
B-3
D-6
D-5
D-10
D-10
E-3
E-3
R136
R236
G-12
F-1
IC101
IC102
IC103
IC104
IC201
IC202
IC204
F-6
F-5
F-5
F-3
F-6
G-5
G-3
Ref. No.
IC301
IC901
IC902
IC903
Location
F-8
B-10
F-9
A-10
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q108
Q109
Q112
Q113
Q114
Q116
Q201
Q202
Q203
Q204
Q205
Q206
Q207
Q208
Q209
Q212
Q213
Q214
Q216
Q801
Q802
Q803
Q804
Q805
Q809
Q810
Q811
Q812
Q813
Q901
Q902
Q903
Q904
Q905
Q906
Q907
Q908
Q909
Q910
Q911
Q912
F-4
E-7
E-9
E-9
E-10
E-10
G-11
C-11
D-11
F-11
G-11
C-12
F-12
G-4
E-5
E-3
E-4
E-3
E-3
G-1
C-1
D-1
F-1
G-1
D-1
G-2
D-7
D-7
B-1
B-1
B-1
A-11
A-12
A-11
B-11
B-11
F-10
F-10
G-10
A-8
A-7
A-5
A-6
A-7
A-6
B-2
B-2
B-3
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
• 2 : nonflammable resistor.
• A : B+ Line.
• B : B– Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from +12V and REMOTE terminals.
• Voltage is dc with respect to ground under no-signal
condition.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Signal path.
F : AUDIO
for printed wiring boards:
• X : parts extracted from the component side.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
• IC Block Diagram
IC901 µPC494GS
16
15
14
13
12
11
10
9
REF. REG.
ERROR
0.1V
OSC
ERROR
1
2
3
4
5
6
7 8
• Waveform
1
1V/DIV, 5µsec/DIV
3.4Vp-p
15µsec
IC901
5
13
XM-2150GSX
SECTION 5
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of
this parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
5-1. HEAT SINK SECTION
1
8
2
3
7
4
7
B
B
#1
#1
A
A
5
F901
#1
7
6
#1
#1
#2
Ref. No.
*
*
*
*
1
2
3
4
5
* 6
14
Part No.
Description
3-239-398-01
3-225-071-02
3-225-065-01
1-681-206-11
3-225-081-02
PLATE (HEAT SINK), ORNAMENTAL
HEAT SINK (MAIN)
HOLDER, LED
LED BOARD
SHEET, INSULATING
3-225-068-02 PLATE, BOTTOM
Remark
#1
Ref. No.
Part No.
Description
7
8
0 F901
#1
#2
3-225-185-01
3-225-153-02
1-533-743-11
7-685-545-14
7-627-556-07
SCREW (+B.TT.3X14)
SHEET (HEAT SINK), ADHESIVE
FUSE (BLADE TYPE) (AUTO FUSE) 40A
SCREW +BTP 3X6 TYPE2 N-S
SCREW, PRECISION +P 2.6X2.8
Remark
XM-2150GSX
5-2. MAIN BOARD SECTION
51
55
53
58
56
63
57
54
52
54
61
63
55
#3
62
59
61
56
59
59
#3
60
Ref. No.
Part No.
Description
* 51
* 52
53
* 54
55
A-3326-762-A
3-225-067-02
3-225-183-01
3-225-080-01
3-225-183-11
MAIN BOARD, COMPLETE
HEAT SINK (SUB 2)
SCREW (+PSW.TT.3XL)
HEAT SINK (RETAINER PLATE)
SCREW (+PSW.TT.3XL)
56
* 57
3-225-066-11 HEAT SINK (SUB 1)
3-225-063-01 BRACKET (2CH.VR1)
Remark
Ref. No.
Part No.
Description
* 58
59
* 60
61
62
3-225-064-01
3-225-184-01
3-225-069-11
3-912-432-01
3-369-647-01
BRACKET (2CH.VR2)
SCREW (+PS.TT.3X6)
PANEL (2CH), FRONT
SCREW (B)
SCREW (M4 SPACER)
63
#3
Remark
3-238-413-01 SHEET (TR), INSULATING
7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT
15
XM-2150GSX
LED
SECTION 6
ELECTRICAL PARTS LIST
MAIN
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
*
1-681-206-11 LED BOARD
**********
Description
*
3-225-065-01 HOLDER, LED
Remark
Ref. No.
Part No.
Description
C106
C107
C108
C110
C111
1-162-927-11
1-107-826-11
1-107-826-11
1-162-919-11
1-136-167-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
100PF
0.1uF
0.1uF
22PF
0.15uF
5%
10%
10%
5%
5%
Remark
50V
16V
16V
50V
50V
C112
C113
C114
C115
C116
1-136-167-00
1-126-794-11
1-126-794-11
1-126-794-11
1-162-923-11
FILM
ELECT
ELECT
ELECT
CERAMIC CHIP
0.15uF
4.7uF
4.7uF
4.7uF
47PF
5%
20%
20%
20%
5%
50V
50V
50V
50V
50V
C117
C118
C119
C120
C123
1-126-794-11
1-127-715-11
1-126-796-11
1-162-927-11
1-126-786-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
4.7uF
0.22uF
22uF
100PF
47uF
20%
10%
20%
5%
20%
50V
16V
35V
50V
16V
C124
C126
C127
C128
C130
1-107-826-11
1-162-921-11
1-107-826-11
1-136-161-00
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
0.1uF
33PF
0.1uF
0.047uF
22PF
10%
5%
10%
5%
5%
16V
50V
16V
50V
50V
C131
C133
C201
C202
C203
1-128-499-11
1-107-826-11
1-126-794-11
1-126-794-11
1-162-919-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
220uF
0.1uF
4.7uF
4.7uF
22PF
20%
10%
20%
20%
5%
16V
16V
50V
50V
50V
C204
C205
C206
C207
C208
1-162-919-11
1-162-927-11
1-162-927-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
100PF
100PF
0.1uF
0.1uF
5%
5%
5%
10%
10%
50V
50V
50V
16V
16V
C210
C211
C212
C213
C214
1-162-919-11
1-136-167-00
1-136-167-00
1-126-794-11
1-126-794-11
CERAMIC CHIP
FILM
FILM
ELECT
ELECT
22PF
0.15uF
0.15uF
4.7uF
4.7uF
5%
5%
5%
20%
20%
50V
50V
50V
50V
50V
C215
C216
C217
C218
C219
1-126-794-11
1-162-923-11
1-126-794-11
1-127-715-11
1-126-796-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
4.7uF
47PF
4.7uF
0.22uF
22uF
20%
5%
20%
10%
20%
50V
50V
50V
16V
35V
C220
C221
C222
C223
C224
1-162-927-11
1-107-826-11
1-162-927-11
1-126-786-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100PF
0.1uF
100PF
47uF
0.1uF
5%
10%
5%
20%
10%
50V
16V
50V
16V
16V
< DIODE >
D808
D809
D810
D811
8-719-064-23 LED SEL2411G (POWER)
8-719-302-91 LED SEL2111R (OVER CURRENT
(PROTECTOR))
8-719-302-91 LED SEL2111R (OFFSET (PROTECTOR))
8-719-302-91 LED SEL2111R (THERMAL (PROTECTOR))
< TRANSISTOR >
Q808
8-729-230-49 TRANSISTOR 2SC2712-YG
< RESISTOR >
R812
R813
R814
R817
R818
1-216-041-00
1-216-061-00
1-216-061-00
1-216-061-00
1-216-041-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
470
3.3K
3.3K
3.3K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R819
1-216-073-00 RES-CHIP
10K
5%
1/10W
*************************************************************
*
A-3326-762-A MAIN BOARD, COMPLETE
*********************
*
*
3-225-063-01
3-225-064-01
3-225-066-11
3-225-067-02
3-225-080-01
BRACKET (2CH.VR1)
BRACKET (2CH.VR2)
HEAT SINK (SUB 1)
HEAT SINK (SUB 2)
HEAT SINK (RETAINER PLATE)
3-225-183-01
3-225-183-11
3-225-184-01
3-238-413-01
3-369-647-01
SCREW (+PSW.TT.3XL)
SCREW (+PSW.TT.3XL)
SCREW (+PS.TT.3X6)
SHEET (TR), INSULATING
SCREW (M4 SPACER)
*
*
3-912-432-01 SCREW (B)
7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT
< CAPACITOR >
C101
C102
C103
C104
C105
16
1-126-794-11
1-126-794-11
1-162-919-11
1-162-919-11
1-162-927-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
22PF
22PF
100PF
20%
20%
5%
5%
5%
50V
50V
50V
50V
50V
XM-2150GSX
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C226
C227
C228
C230
C231
1-162-921-11
1-107-826-11
1-136-161-00
1-162-919-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
33PF
0.1uF
0.047uF
22PF
0.1uF
5%
10%
5%
5%
10%
50V
16V
50V
50V
16V
Remark
Ref. No.
C936
C937
C938
C939
C940
1-128-499-11
1-126-767-11
1-128-576-11
1-128-576-11
1-164-161-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
220uF
1000uF
100uF
100uF
0.0022uF
20%
20%
20%
20%
10%
Remark
16V
16V
63V
63V
100V
C233
C301
C302
C303
C304
1-107-826-11
1-162-970-11
1-164-174-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.0082uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
25V
25V
25V
25V
C941
C942
C943
C944
C950
1-164-161-11
1-131-731-11
1-164-161-11
1-164-161-11
1-162-970-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
2200uF
0.0022uF
0.0022uF
0.01uF
10%
20%
10%
10%
10%
100V
16V
100V
100V
25V
C305
C801
C802
C803
C804
1-107-826-11
1-126-796-11
1-162-964-11
1-126-786-11
1-115-339-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
22uF
0.001uF
47uF
0.1uF
10%
20%
10%
20%
10%
16V
35V
50V
16V
50V
C805
C806
C807
C808
C809
1-162-964-11
1-126-796-11
1-162-962-11
1-162-962-11
1-126-794-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001uF
22uF
470PF
470PF
4.7uF
10%
20%
10%
10%
20%
50V
35V
50V
50V
50V
C810
C901
C902
C903
C904
1-162-964-11
1-115-339-11
1-115-339-11
1-164-161-11
1-164-161-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.1uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
50V
50V
50V
100V
100V
CNJ801 1-779-078-41 JACK, PIN 4P (INPUT,OUTPUT (THROUGH))
C905
C906
C909
C911
C912
1-164-161-11
1-164-161-11
1-130-471-00
1-128-126-11
1-128-126-11
CERAMIC CHIP
CERAMIC CHIP
MYLAR
ELECT
ELECT
0.0022uF
0.0022uF
0.001uF
100uF
100uF
10%
10%
5%
20%
20%
100V
100V
50V
25V
25V
D101
D102
D103
D104
D201
8-719-065-43
8-719-065-43
8-719-065-43
8-719-065-43
8-719-065-43
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
C913
C914
C915
C916
C917
1-162-964-11
1-162-964-11
1-137-194-11
1-164-227-11
1-131-731-11
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
ELECT
0.001uF
0.001uF
0.47uF
0.022uF
2200uF
10%
10%
5%
10%
20%
50V
50V
50V
25V
16V
D202
D203
D204
D301
D302
8-719-065-43
8-719-065-43
8-719-065-43
8-719-016-74
8-719-016-74
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
1SS352
1SS352
C918
C919
C920
C921
C922
1-131-731-11
1-131-731-11
1-126-973-21
1-126-973-21
1-126-973-21
ELECT
ELECT
ELECT
ELECT
ELECT
2200uF
2200uF
2200uF
2200uF
2200uF
20%
20%
20%
20%
20%
16V
16V
50V
50V
50V
D801
D802
D803
D805
D807
8-719-065-18
8-719-016-74
8-719-016-74
8-719-016-74
8-719-016-74
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ6.8-Y(TPH3)
1SS352
1SS352
1SS352
1SS352
C923
C924
C925
C926
C927
1-126-973-21
1-115-339-11
1-115-339-11
1-126-973-21
1-126-973-21
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
2200uF
0.1uF
0.1uF
2200uF
2200uF
20%
10%
10%
20%
20%
50V
50V
50V
50V
50V
D820
D821
D824
D825
D826
8-719-016-74
8-719-016-74
8-719-016-74
8-719-016-74
8-719-016-74
DIODE
DIODE
DIODE
DIODE
DIODE
1SS352
1SS352
1SS352
1SS352
1SS352
C928
C929
C930
C931
C932
1-126-973-21
1-126-973-21
1-115-339-11
1-115-339-11
1-128-126-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
2200uF
2200uF
0.1uF
0.1uF
100uF
20%
20%
10%
10%
20%
50V
50V
50V
50V
25V
D827
D830
D831
D901
D902
8-719-016-74
8-719-016-74
8-719-016-74
8-719-065-18
8-719-065-46
DIODE
DIODE
DIODE
DIODE
DIODE
1SS352
1SS352
1SS352
02DZ6.8-Y(TPH3)
02DZ16-Z(TPH3)
C933
C934
C935
1-128-126-11 ELECT
1-136-165-00 FILM
1-136-165-00 FILM
100uF
0.1uF
0.1uF
20%
5%
5%
25V
50V
50V
D905
D906
D907
8-719-079-00 DIODE FCH10A15
8-719-079-01 DIODE FRH10A15
8-719-079-00 DIODE FCH10A15
< TERMINAL BOARD >
CN801
CN804
CN805
1-694-755-11 TERMINAL BOARD (2P+FUSE) (+12V,GND)
1-694-754-11 TERMINAL BOARD (2P) (SPEAKER OUT L)
1-694-754-11 TERMINAL BOARD (2P) (SPEAKER OUT R)
< CONNECTOR >
CN802
CN803
* CN806
1-815-300-11 CONNECTOR 1P (REM)
1-794-219-11 CONNECTOR 4P (HIGH LEVEL (INPUT))
1-568-954-11 PIN, CONNECTOR 5P
< JACK >
< DIODE >
17
XM-2150GSX
MAIN
Ref. No.
Part No.
Description
Part No.
Description
D908
D909
D910
D911
D912
8-719-079-01
8-719-054-55
8-719-054-55
8-719-053-18
8-719-053-18
DIODE
DIODE
DIODE
DIODE
DIODE
FRH10A15
1SS306-TE85L
1SS306-TE85L
1SR154-400TE-25
1SR154-400TE-25
Remark
JR123
JR124
JR125
JR126
JR127
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D913
D914
D915
D917
D918
8-719-065-43
8-719-065-43
8-719-065-18
8-719-053-18
8-719-053-18
DIODE
DIODE
DIODE
DIODE
DIODE
02DZ15-Z(TPH3)
02DZ15-Z(TPH3)
02DZ6.8-Y(TPH3)
1SR154-400TE-25
1SR154-400TE-25
JR128
JR129
JR130
JR131
JR132
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D919
D920
D921
D922
R136
8-719-016-74
8-719-016-74
8-719-016-74
8-719-016-74
8-719-422-16
DIODE
DIODE
DIODE
DIODE
DIODE
1SS352
1SS352
1SS352
1SS352
MA8039-L-TX
JR133
JR134
JR135
JR136
JR137
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
R236
8-719-422-16 DIODE MA8039-L-TX
JR138
JR139
JR140
JR141
JR142
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR143
JR144
JR145
JR146
JR147
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR148
JR149
JR200
JR201
JR203
1-216-295-11
1-216-295-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR204
JR206
JR207
JR209
JR210
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR212
JR213
JR214
JR221
JR224
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR228
JR232
JR233
JR234
JR235
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR236
JR237
JR238
JR240
JR241
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR242
JR243
JR246
1-216-296-11 SHORT
1-216-296-11 SHORT
1-216-296-11 SHORT
0
0
0
< IC >
IC101
IC102
IC103
IC104
IC201
8-759-385-17
8-759-385-17
8-759-385-17
8-759-385-17
8-759-385-17
IC
IC
IC
IC
IC
NJM4580E(TE2)
NJM4580E(TE2)
NJM4580E(TE2)
NJM4580E(TE2)
NJM4580E(TE2)
IC202
IC204
IC301
IC901
8-759-385-17
8-759-385-17
8-759-385-17
8-759-144-88
IC
IC
IC
IC
NJM4580E(TE2)
NJM4580E(TE2)
NJM4580E(TE2)
uPC494GS
< PHOTO TRANSISTOR >
IC902
IC903
8-719-800-42 PHOTO TRANSISTOR TLP521-1-A
8-719-800-42 PHOTO TRANSISTOR TLP521-1-A
< JUMPER RESISTOR >
JR100
JR101
JR102
JR104
JR105
1-216-295-11
1-216-295-11
1-216-295-11
1-216-041-00
1-216-295-11
SHORT
SHORT
SHORT
METAL CHIP
SHORT
0
0
0
470
0
JR106
JR107
JR109
JR110
JR111
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR112
JR113
JR114
JR115
JR117
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR118
JR119
JR120
JR121
JR122
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
18
5%
1/10W
Ref. No.
Remark
XM-2150GSX
MAIN
Ref. No.
Part No.
Description
Part No.
Description
JR251
JR254
JR259
JR260
JR261
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
Remark
Q813
Q901
Q902
Q903
Q904
8-729-216-22
8-729-052-82
8-729-216-22
8-729-230-49
8-729-053-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET FKV550T
JR262
JR264
JR265
1-216-296-11 SHORT
1-216-296-11 SHORT
1-216-296-11 SHORT
0
0
0
Q905
Q906
Q907
Q908
Q909
8-729-053-05
8-729-053-05
8-729-053-05
8-729-230-49
8-729-230-49
FET FKV550T
FET FKV550T
FET FKV550T
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
Q910
Q911
Q912
8-729-207-82 TRANSISTOR 2SC3421-Y
8-729-207-89 TRANSISTOR 2SA1358-Y
8-729-230-49 TRANSISTOR 2SC2712-YG
< COIL >
L901
L902
1-419-851-11 COIL, CHOKE
50uH
1-410-396-41 INDUCTOR, FERRITE BEAD 0.45uH
Ref. No.
Remark
2SA1162-G
KTA1281Y-AT
2SA1162-G
2SC2712-YG
< PILOT LAMP >
< RESISTOR >
PL801
1-517-156-11 LAMP, PILOT (65mA/14V)
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-141-73
8-729-202-38
8-729-014-87
8-729-014-85
8-729-207-89
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3624A-T1L15L16
2SC3326N-A
2SC4207-YGR-TE85R
2SA1618-YGR-TE85R
2SA1358-Y
Q106
Q107
Q108
Q109
Q112
8-729-207-82
8-729-055-13
X-3381-586-1
X-3381-587-1
X-3381-586-1
TRANSISTOR 2SC3421-Y
TRANSISTOR 2SD1861-TV2
FET IRF540 (2 PCS)
FET IRF9540 (2 PCS)
FET IRF540 (2 PCS)
Q113
Q114
Q116
Q201
Q202
X-3381-587-1
8-729-230-49
8-729-230-49
8-729-141-73
8-729-202-38
FET IRF9540 (2 PCS)
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC2712-YG
TRANSISTOR 2SC3624A-T1L15L16
TRANSISTOR 2SC3326N-A
Q203
Q204
Q205
Q206
Q207
8-729-014-87
8-729-014-85
8-729-207-89
8-729-207-82
8-729-055-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q208
Q209
Q212
Q213
Q214
X-3381-586-1
X-3381-587-1
X-3381-586-1
X-3381-587-1
8-729-230-49
FET IRF540 (2 PCS)
FET IRF9540 (2 PCS)
FET IRF540 (2 PCS)
FET IRF9540 (2 PCS)
TRANSISTOR 2SC2712-YG
Q216
Q801
Q802
Q803
Q804
8-729-230-49
8-729-216-22
8-729-230-49
8-729-230-49
8-729-216-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-YG
2SA1162-G
2SC2712-YG
2SC2712-YG
2SA1162-G
Q805
Q809
Q810
Q811
Q812
8-729-230-49
8-729-230-49
8-729-230-49
8-729-216-22
8-729-230-49
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-YG
2SC2712-YG
2SC2712-YG
2SA1162-G
2SC2712-YG
2SC4207-YGR-TE85R
2SA1618-YGR-TE85R
2SA1358-Y
2SC3421-Y
2SD1861-TV2
R101
R102
R103
R104
R105
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-206-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
22K
22K
22K
22K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/8W
R106
R107
R109
R110
R111
1-216-845-11
1-216-845-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R112
R113
R114
R115
R116
1-216-837-11
1-216-833-11
1-216-833-11
1-216-827-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
22K
10K
10K
3.3K
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R117
R118
R119
R120
R121
1-216-827-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-843-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
100K
100K
100K
68K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R122
R123
R124
R125
R126
1-216-295-11
1-216-827-11
1-216-045-00
1-216-837-11
1-216-829-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
3.3K
680
22K
4.7K
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
R127
R128
R129
R130
R131
1-216-833-11
1-216-813-11
1-216-833-11
1-216-829-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
220
10K
4.7K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R132
R133
R134
R135
R137
1-216-825-11
1-216-093-00
1-216-093-00
1-216-025-11
1-216-829-11
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
2.2K
68K
68K
100
4.7K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/16W
R138
R139
R140
1-216-025-11 RES-CHIP
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100
100K
100K
5%
5%
5%
1/10W
1/16W
1/16W
19
XM-2150GSX
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R141
R142
R143
R144
R145
1-216-017-00
1-216-017-00
1-249-427-11
1-249-421-11
1-220-894-11
RES-CHIP
RES-CHIP
CARBON
CARBON
METAL
47
47
6.8K
2.2K
0.22X2
5%
5%
5%
5%
10%
1/10W
1/10W
1/4W
1/4W
5W
R234
R235
R237
R238
R239
1-216-093-00
1-216-025-11
1-216-829-11
1-216-025-11
1-216-845-11
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
68K
100
4.7K
100
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/16W
R146
R149
R150
R151
R152
1-220-894-11
1-220-894-11
1-216-825-11
1-216-821-11
1-215-859-00
METAL
METAL
METAL CHIP
METAL CHIP
METAL OXIDE
0.22X2
0.22X2
2.2K
1K
22
10%
10%
5%
5%
5%
5W
5W
1/16W
1/16W
1W
F
R240
R241
R242
R243
R244
1-216-845-11
1-216-017-00
1-216-017-00
1-249-427-11
1-249-421-11
METAL CHIP
RES-CHIP
RES-CHIP
CARBON
CARBON
100K
47
47
6.8K
2.2K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/4W
1/4W
R153
R154
R155
R156
R157
1-216-853-11
1-216-065-00
1-216-077-00
1-216-833-11
1-220-894-11
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL
470K
4.7K
15K
10K
0.22X2
5%
5%
5%
5%
10%
1/16W
1/10W
1/10W
1/16W
5W
R245
R246
R249
R250
R251
1-220-894-11
1-220-894-11
1-220-894-11
1-216-825-11
1-216-821-11
METAL
METAL
METAL
METAL CHIP
METAL CHIP
0.22X2
0.22X2
0.22X2
2.2K
1K
10%
10%
10%
5%
5%
5W
5W
5W
1/16W
1/16W
R158
R159
R160
R165
R167
1-216-825-11
1-216-821-11
1-215-859-00
1-216-833-11
1-216-017-00
METAL CHIP
METAL CHIP
METAL OXIDE
METAL CHIP
RES-CHIP
2.2K
1K
22
10K
47
5%
5%
5%
5%
5%
1/16W
1/16W
1W
F
1/16W
1/10W
R252
R253
R254
R255
R256
1-215-859-00
1-216-853-11
1-216-049-11
1-216-077-00
1-216-833-11
METAL OXIDE
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
22
470K
1K
15K
10K
5%
5%
5%
5%
5%
1W
F
1/16W
1/10W
1/10W
1/16W
R168
R201
R202
R203
R204
1-216-017-00
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R257
R258
R259
R260
R265
1-220-894-11
1-216-825-11
1-216-821-11
1-215-859-00
1-216-833-11
METAL
METAL CHIP
METAL CHIP
METAL OXIDE
METAL CHIP
0.22X2
2.2K
1K
22
10K
10%
5%
5%
5%
5%
5W
1/16W
1/16W
1W
F
1/16W
R205
R206
R207
R209
R210
1-216-206-00
1-216-845-11
1-216-845-11
1-216-833-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
100K
10K
10K
5%
5%
5%
5%
5%
1/8W
1/16W
1/16W
1/16W
1/16W
R267
R268
R301
R302
R303
1-216-017-00
1-216-017-00
1-216-833-11
1-216-829-11
1-216-833-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
47
10K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R211
R212
R213
R214
R215
1-216-833-11
1-216-837-11
1-216-833-11
1-216-833-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
10K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R304
R305
R306
R307
R308
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R216
R217
R218
R219
R220
1-218-867-11
1-216-827-11
1-216-845-11
1-216-845-11
1-216-845-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
3.3K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R309
R310
R311
R312
R313
1-216-847-11
1-216-847-11
1-216-833-11
1-216-833-11
1-220-397-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
150K
150K
10K
10K
4.7M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R221
R222
R223
R224
R225
1-216-843-11
1-216-295-11
1-216-827-11
1-216-045-00
1-216-837-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
68K
0
3.3K
680
22K
5%
1/16W
5%
5%
5%
1/16W
1/10W
1/16W
R314
R315
R801
R802
R803
1-220-397-11
1-216-845-11
1-216-857-11
1-216-821-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7M
100K
1M
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R226
R227
R228
R229
R230
1-216-829-11
1-216-833-11
1-216-813-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
220
10K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R804
R805
R806
R807
R808
1-216-845-11
1-216-839-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
33K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R231
R232
R233
1-216-825-11 METAL CHIP
1-216-825-11 METAL CHIP
1-216-093-00 RES-CHIP
2.2K
2.2K
68K
5%
5%
5%
1/16W
1/16W
1/10W
R809
R810
R811
1-216-833-11 METAL CHIP
1-216-857-11 METAL CHIP
1-216-206-00 RES-CHIP
10K
1M
2.2K
5%
5%
5%
1/16W
1/16W
1/8W
20
Remark
Ref. No.
Remark
XM-2150GSX
MAIN
Ref. No.
Part No.
Description
R820
R821
R822
R823
R824
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
47K
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R825
R826
R827
R828
R829
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R830
R838
R839
R840
R841
1-216-833-11
1-216-821-11
1-216-857-11
1-216-820-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
1M
820
820
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R844
R845
R846
R847
R850
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
820
820
820
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R851
R852
R901
R902
R903
1-216-820-11
1-216-820-11
1-216-828-11
1-216-827-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
820
3.9K
3.3K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R904
R905
R906
R907
R908
1-216-835-11
1-216-848-11
1-216-065-00
1-216-190-00
1-216-190-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
15K
180K
4.7K
470
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/8W
1/8W
R909
R910
R911
R912
R913
1-216-061-00
1-216-073-00
1-216-073-00
1-216-186-00
1-216-049-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
10K
10K
330
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
R914
R915
R916
R917
R918
1-216-049-11
1-216-009-00
1-216-001-00
1-216-009-00
1-216-186-00
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
1K
22
10
22
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R919
R920
R921
R922
R923
1-216-186-00
1-216-001-00
1-216-001-00
1-216-001-00
1-216-825-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
10
10
10
2.2K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/16W
R924
R925
R926
R927
R928
1-216-825-11
1-216-081-00
1-216-081-00
1-216-833-11
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.2K
22K
22K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/16W
1/10W
R929
R930
R931
1-216-033-00 METAL CHIP
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
220
1K
1K
5%
5%
5%
1/10W
1/16W
1/16W
Ref. No.
R932
R933
R934
R942
R943
Part No.
Description
1-216-821-11
1-216-821-11
1-216-821-11
1-216-186-00
1-216-186-00
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
Remark
1K
1K
1K
330
330
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/8W
1/8W
< VARIABLE RESISTOR >
RV103
RV104
RV801
1-225-648-12 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz))
1-225-648-12 RES, VAR, CARBON 5KX2 (LEVEL)
1-225-647-11 RES, VAR, CARBON 20KX4 (FILTER)
< CERMET RESISTOR >
RV105
RV205
1-241-765-11 RES, ADJ, CERMET 22K
1-241-765-11 RES, ADJ, CERMET 22K
< SWITCH >
S301
S801
1-762-638-11 SWITCH, TACTILE (TEST TONE)
1-572-185-11 SWITCH, SLIDE (FILTER)
< TRANSFORMER >
T901
1-435-857-11 TRANSFORMER, DC-DC CONVERTER
< THERMISTOR (NEGATIVE) >
TH801
TH802
TH803
TH806
TH807
1-804-301-11
1-804-301-11
1-804-301-11
1-804-301-11
1-804-301-11
THERMISTOR, CHIP (NEGATIVE)
THERMISTOR, CHIP (NEGATIVE)
THERMISTOR, CHIP (NEGATIVE)
THERMISTOR, CHIP (NEGATIVE)
THERMISTOR, CHIP (NEGATIVE)
TH808 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)
TH809 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)
TH812 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)
TH813 1-804-301-11 THERMISTOR, CHIP (NEGATIVE)
*************************************************************
MISCELLANEOUS
***************
0 F901
1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) 40A
*************************************************************
ACCESSORIES
************
3-239-425-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
3-367-410-01 SCREW (DIA.5X15), TAPPING
(MOUNTING SCREW)
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
21
XM-2150GSX
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
22
Date
2001. 12
Description of Revision
New