Lumex - splash bath lift

LUMEJf
splash™
bath lift
LUMEJf
powered by
'"\l"m~tway·
Please ensure both yourself and any helpers read these operating instructions
carefully and in full before using your bath lift. These operating instructions should
be retained for future reference.
This bath lift is designed and m anufactured to assist individuals in getting in and out of the
tub. It shou ld not be m ed for any o ther purpose. Do not use it in combination w ith o ther
lifting or moving devices. Ifyo u are unable to get out of the t ub unaided, do not bathe
w ithout someone on ca II to help in an e m ergency .
Quick start guide
This guide should be read in conjunction with your bath lift-'s full operating
instructions, which start on page 4.
l.Charge the battery by sliding it into the tracks on
the charging cradle (fig 1) and plugging it into a
power soc keVoutlet.
d
Tracks
Charging cradle
~ . ~;..
When the light is constant red, it is cNug ing. When the light is constant green, it is ready Charger
to use. 2.PNpare the tub by removing:
Non-slip mats, oil and cleane:r residues; Obstructions such as handles (or fit side Oap protectors~ handraits ancl soap dishes; ~
\
Battery
Overhead obstructions at the rear ard over the tub
such as cupboards. shelves.
3.1nstall the bath lift by:
Placing it w ith the suction fret on the flat bottom of
the tub and at the opposite end to the faucets;
Figure 1
Actuator casing
Checking forany obstructions likely to interfere with
the bath liftS movement (move the bath lift foJWarcl
if there are fixed oveffiead obstacles):
Pressing firmly on the seat to secure the suction feet to the tub ; Then: Unfold the two side flaps to rest against the sides of the tub; Run water to any level under the actuatorcasing
(fig 2).
4. Use the bath lift by:
Slid ing the charged battery fully into t he tracks on
the hand control (ftg 3);
Pressing the UP button.
Figure 2
Only continue if the light on the hand control is
constant or flashing green and if the battery has been
charged within the last 7-10 days.
When the seat reaches the top of the tub:
• ReleaseyourfingerfromtheUPbutton;
• Sitonthesideflapandrotateontotheseat;
• Extend
yourfeetoutinfrontofyouandkeepyour
handsabovetheseat;
Tracks
• PresstheDOWNbuttononthehandcontrol;
• Attachthehandcontrolandbatterytotheedgeof
the tub or to a tiled wall.
Forconvenienceduringbathing,youmayraiseorlower
theseattoanydesiredheightbypressingtheUPor
DOWNbuttonandreleasingittostop.
Whenyouhavefinishedbathing:
• Retrievethebatteryandhandcontrol;
• Press
theUPbuttonuntilthesideflapsarelevel
withthetopofthetub;
Hand control
Battery
Figure 3
Top of
backrest
Suction
release tag
• ReleasetheUPbuttonandmoveontothesideflap;
• Turnwhileliftingeachlegoutofthetub;
• Drainthetub.
5. When you are not using the bath lift:
• Disconnectthebatteryandplaceoncharge;
• Storetheliftatthebottomofthetub.
Toremovetheliftfromthetub,placeitinits
lowest position and:
• Disconnectthebatteryfromthehandcontrol;
• Placethehandcontrolontheseat;
Figure 4
Cable coil
Actuator casing
• Foldinthesideflaps;
• While
holdingthetopofthebackrest,pullthe
suction release tags on the rear suction feet then
tilt the bath lift forward (fig 4);
• Release
thetagsonthefrontsuctionfeetandlift
thebathliftoutofthetub;
• Wrap
thehandcontrolcableclockwisearound
the seat, positioning the cable coil under the
actuatorcasing;
• Loop
theremainderofthecablearoundoneof
the tubes(fig 5);
• Storethebathliftuprightoronitsside.
Figure 5
3
Figures
1
O Hand control
0 Bath Lift
(t Side flap
E) Suction feet
2
G
,1/
c
() Battery
Q Charger
8
Charging cradle
0
Light indicator
Q
Tracks
I
I
()
3
( ) Integral tub hand le
O
Side flap protector
e
4
0
0
8
X
Integral tub handle
Side flap protector
Side flap
L
•
5
O Side flap
Q
Actuator casing
Cl Hand control
6
O Battery
() Tracks
8
Hand control
8
7
0
Hand control
Q
Battery status indicator
(D Down
8
0
Top of backrest
Q
Suction release tag
9
O Cablecoil
E)
Actuator casing
Operating instructions
Contents
Unpacking the bath lift
Warranties, maintenance & servicing
1.Unpackingthebathlift . . . . . . . . . . . . . 5
10. Maintenance and servicing . . . . . . . 11
11. Warranty . . . . . . . . . . . . . . . . . . . . . . . . 12
Before you start
2. Charging the battery . . . . . . . . . . . . . . . 5
3.Preparingthetubforinstallation . . . . . . . . .6 4. Installing the bath lift . . . . . . . . . . . . . . . 7
Using the bath lift
5. Connecting the hand control . . . . . . . 8 6.Usingthebathlift . . . . . . . . . . . . . . . . . . 8
Removing and storing the bath lift
7. When the bath lift is not in use . . . 10 8.Removingthebathliftfrom
the tub . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 9. Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 11 4
Symbols
12.Symbols . . . . . . . . . . . . . . . . . . . . . . . . . 12
Technical data
13.Technicaldata . . . . . . . . . . . . . . . . . . . . 13
Troubleshooting
14.Troubleshooting . . . . . . . . . . . . . . . . . . 15
Parts list
15.Accessories . . . . . . . . . . . . . . . . . . . . . . 18
16.Partslist . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Diagrams for operation and explanation of use are on the
fold-out diagram sheet attached to the rear of this booklet
1. Unpacking the bath lift
Openthepackagingandensurethebathliftisnotdamagedandthatallpartsareincluded.Ifithas
beendamagedintransitorpartsaremissing,contactyoursupplierimmediately.
Insidetheboxyouwillfind:
• Abathlift,completewithtwosideflapsandhandcontrolattached(see fig 1)
• Abattery(see fig 2)
• Abatterychargerwithchargingcradleattached(see fig 2)
Ifyourbathliftissuppliedwithoptionalsoftcovers,fitthematthisstage
(seecoverfittinginstructions).
Beforeinstallingorusingthebathliftforthefirsttime,ensureyouchargethebattery
(seesection2,“Chargingthebattery”below).
2. Charging the battery
Before first operation of your bath lift or after long periods of non-use (typically 7-10 days),
fully charge the battery as follows. A flat battery will take up to 2 hours to charge.
i) Slidethebatteryintothetracksonthechargingcradleuntilitclicksintoplace(see fig 2).
thechargerintoasocket/outletoutsidethebathroomandswitchontheelectricitysupply
ii) Plug
(ifapplicable).
lightindicatoronthechargerboxwillinitiallyflashinaquicksequenceofred,green,red,
iii) The
green, before a constant red light appears to indicate charging is in progress (see fig 2).
thebatteryhasbeenfullycharged,theredlightonthechargerboxturnstoaconstant
iv) When
greenlight,whichindicatesthebatteryisreadyforuse.Werecommendchargingthebattery
aftereachbathwhereverpossibleandleavingitonchargeuntilyournextbath.Thebattery
cannot be overcharged.
youarereadytouseyourfullychargedbattery(seeparagraphiv),switchoffthesocket/
v) When
outletorremovethechargerfromthesocket/outlet,then ensure you disconnect the battery
from the charging cradle.(Thispreventsthebatterydischargingandwillresetthecharger
readyforitsnextuse.)
5
NOTE:
• Donotchargeinthebathroomoranyhumidarea.Alwayschargeinadryarea,ensuringyour
handsaredryfirst.
•Donotcoverthebatteryorchargerwhilecharging.
•Alwayschargeonahardsurface.
•Duringcharging,thetemperatureofthechargerboxmayexceed40oC/104oF but will gradually
decreaseoncetheconstantgreenlightontheboxappears.Userswithsensitive/damagedskin
shouldtakecareandallowapproximately3hoursfromstartofchargingbeforehandlingthebox.
•Ensurethatnometalobjectstouchthecontactsonthebattery,asthiswilldamagethebattery.
•UseonlytheLumex®Splashchargersuppliedtochargethebatteryandfornootherpurpose.
3. Preparing the tub for installation
i) Removeanynon-slipmatsfromthetub.
ii) Ensure
thebottomofthetubiscleanandsmooth,withnooilortubcleanerresiduesthatwill
preventthesuctionfeetfromsticking.
iii) The
suctionfeetmaynotbesuitableintubsthathavebeenre-enamelledorthathaverippledor
texturedsurfaces.
iv) Itisessentialthatthesideflaps(see fig 1) do not catch under any obstructions such as integral
tub handles, handrails, soap dishes and faucets when rising. If your tub has integral handles
andthesideflapsarelikelytocatch,optionalsideflapprotectorsareavailable(seesection15,
“Accessories”).Thesehookoverintegraltubhandles (see fig 3) and help guide the side flaps
smoothlyoverthehandles.
v) Ensuretherearenooverheadobstructionsattherearofthetub,wherethebathliftwillbe
positioned(e.g.wall-mountedshelves/cupboardsorshowerfixtures),astheymayinterferewith
theupwardmovementoftheseat.Wherepossible,removesuchobstructions.Alternatively,
thebathliftmustbeplacedfurtherforwardinthetubtoavoidtheobstruction(seesection4,
“Installingthebathlift”).
6
4. Installing the bath lift
i) Pickupthebathliftholdingitascloseaspossibletoyourbody.
ii) Placethesuctionfeetontheflatbottomofthetubandasfarbackaspossibleattheopposite
endtothefaucets.Ifthereareanyoverheadobstructionsatthebackofthetubthatcannotbe
removedandarelikelytointerferewiththeupwardmovementofthebathlift,movethebathlift
further forward in the tub until clear of the obstacle.
iii) Now
pressfirmlydownontheseat,ensuringallfoursuctionfeetareattachedtothetubsurface.
NOTE:
Thesuctionfeetmaynotsticktoverycurvedorcontouredsurfaces.
iv) Unfold
thetwosideflapssotheyrestagainstthesidesofthetub.(Sideflapseasetransfer
onandoffthebathliftandalsopreventfingerentrapment.)Ifsideflapprotectorsarerequired
andhavebeenfittedtointegraltubhandles,ensurethetwosideflapsarerestingsubstantiallyon
them.Ifthesideflapsarestilllikelytocatchunderhandles,movethesideflapprotectorsasfaras
possiblealongthehandlesuntilthesideflapsareoverthem (see fig 4).
Ifthisstilldoesnotimprovetheflaps’positiononthesideflapprotectors,movethebathlift
slightlyforwardinthetub.Alternatively,asideflapprotectorextensionkitisavailable(seesection
15,“Accessories”).
v) Fill
thetubwithwatertotherequiredlevelensuringtheactuatorcasing(see fig 5) is not
submergedinwater.Checkthatthewatertemperatureisnottoohotbeforeusingthebathlift.
NOTE:
Water level will rise when your body enters the tub and
displaces the water.
Thedepthofthewaterisnottoexceedthedepthas
indicatedbythelabel(seeright)onthebackandsides
oftheLumex®Splash.
vi) The
batterycannowbeconnectedtothehandcontrolonyourbathlift(seesection5,
“Connectingthehandcontrol”).
7
5. Connecting the hand control
NOTE:
If the battery has not been used before or has not been used for a long period (typically 7-10
days),ensureyouplaceitonchargebeforeusingthebathlift.
i) Slidethefullychargedbatteryintothetracksonthehandcontrol(see fig 6)untilitclicks
into place.
ii) Alwayscheckthebatterystatusindicatoronthehandcontrolbeforeusingthebathlift
(see fig 7).PresstheUPbuttonandobservethefollowingguidelines:
• If GREENlight,proceedwithyourbath,providedthebatteryhasbeenchargedwithinthe
last 7-10 days.
• If FLASHINGGREENlight,proceedwithyourbath,providedthebatteryhasbeenchargedwithin
thelast7-10days.Thenchargeimmediatelyafterwards(seesection2,“Chargingthebattery”).
• If REDlight,doNOT use the bath lift. Charge IMMEDIATELY (seesection2,“Charging
thebattery”).
• Ifinanydoubt,rechargethebatterybeforeuse(seesection2,“Chargingthebattery”).
NOTE:
The
batteryisforusesolelywithLumex®Splash bath lifts and cannot be used to operate any
other product.
6. Using the bath lift
NOTE:
Ensureallfoursuctionfeetareattachedtothetubsurfacebeforeeachuse.
i) To
raisethebathlift,presstheUPbuttononthehandcontrol(see fig 7). If the side flaps are
caughtonanyobstruction,immediatelylowerthebathliftbypressingtheDOWNbuttononthe
handcontrol.Pulleachsideflapfreefromtheobstruction,thenresumetheliftingoperation.
thebathliftreachesthetopofthetub,thesideflaponthesideyouwillbegettingonwillfold
ii) As
outtoformatransferplatform.
thebathlift’sseatandsideflaparelevelwithandsupportedbythetopofthetub,release
iii) When
yourfingerfromtheUPbuttonandthebathliftwillstop.
onthesideflapandmoveontotheseat,ensuringnopartofyourbodycanbecometrapped
iv) Sit
asyoudoso(e.g.underneaththesideflaps).Youmayfinditeasiertotransferifyouwettheseat
andthesideflapsfirst.Turnasyoulifteachlegoverthesideofthetubthensitbackintheseat
andmakeyourselfcomfortable.
8
v) Beforeloweringthebathlift,extendyourfeetoutinfrontofyouandkeephandsabovetheseat
toavoidanyriskofentrapment.
vi) Toloweryourselftothebottomofthetub,presstheDOWNbuttononthehandcontrol
(see fig 7).Whenthebuttonisreleased,thebathliftwillstopandremainatthatpositionuntil
the button is pressed again.
vii) Whenyouhavereachedthebottomofthetub,thebathliftwillautomaticallystop.
viii)While
bathing,youmayusethesuctioncupsonthebatterytoattachthehandcontrol
and battery to the edge of the tub or to a tiled wall. If the hand control and battery fall into
the water, there is NO danger as both are waterproof. Ensure you wipe the battery dry
before charging.
ix) When
youhavefinishedbathing,retrievethebatteryandhandcontrolfromwhereyouhave
storeditbypullingthetagsonthesuctioncups.PresstheUPbuttontoraisethebathlift.When
thebuttonisreleased,thebathliftwillstopandremainatthatpositionuntilthebuttonis
pressed again.
x) Once
thesideflapsarelevelwiththetopofthetub,removeyourfingerfromtheUPbuttonand
movesidewaysontothesideflap,ensuringonceagainthatnopartofthebodycanbecome
trapped as you do so.
xi) Turn
whileliftingeachlegoutofthetub.
xii)Drainthetub.
NOTE:
• IftheREDlightappearsonthehandcontrolwhilelowering,thebathliftwillnotgodownany
further.Ifthishappens,presstheUPbuttonandthebathliftwillraiseyoutothetopofthetub.
Charge the battery immediately.
•In
theeventofanemergency,slidingthebatteryoutofthehandcontrolcaninstantly
terminateallbathliftmovement.
• Whenthebathliftreachesitsmaximumlimitoftravel(upordown),therewillbeashortdelay
before it will operate again.
•Thebathliftisnotdesignedforcontinuousoperation.Allowatleast15minutesbetweenbaths.
•Do
NOTallowtheactuatorbehindthebackresttobeplacedunderaconstantflowofwater
(e.g.runningfaucet)andensureitisnottotallysubmergedinwater.
9
7. When the bath lift is not in use
i) If youwishtocleanthebathliftwhileitisinthetub(seesection9,“Cleaning”),werecommend
doingsowhenitisatitshighestpositioninthetub.Thisallowsaccessforcleaningboththetub
and the underside of the bath lift.
ii) If the bath lift is stored in the tub, ALWAYS ensure the seat is lowered to the bottom of
the tub.
NOTE:
If the RED light has appeared on the hand control preventing you from lowering the
bath lift to the bottom of the tub for storage, recharge the battery immediately
(see section 2, “ Charging the battery”) and lower the bath lift to the bottom of the tub
as soon as possible thereafter.
thebatteryandplaceonchargereadyforyournextbath(seesection2,“Charging
iii) Disconnect
thebattery”).Note: If not charging after each bath, ensure you leave the battery connected
to the hand control. Disconnectfromthehandcontrolonlyifthebathliftisbeingremoved
fromthetub.
8. Removing the bath lift from the tub
Ensurethebathliftisinitslowestpositionatthebottomofthetub.
Removethebatteryfromthehandcontrol.
Placethehandcontrolontheseatandfoldthesideflapsin.
thetopofthebackrestandasyoupullthereleasetagsoneachoftherearsuction
Hold
feet, tilt the bath lift forward (see fig 8).
toreleasethetagsonthefrontsuctionfeetandliftthecompletebathliftoutofthe
v) Continue
tub.
thebathliftupright,thenwrapthehandcontrolcableclockwisearoundboththeseat
vi) Stand
andtubesensuringthecablecoilispositionedunderneaththeactuatorcasing.Nowloopthe
remainderofthecablearoundoneofthetubes(see fig 9).
vii) Storethebathliftuprightorlayitonitsside.
i)
ii)
iii)
iv)
NOTE:
•Whenliftingthebathlift,alwaysliftclosetoyourbody.
• To
avoidaccidentaldamagetothehandcontrolwhilecarryingorstoring,ensureitis
preventedfromdanglingfreely.
10
9. Cleaning
Cleanthebathliftasfrequentlyasyoucleanyourtub,usingnon-abrasivecleaners.*Ifused
communally,werecommenddisinfectingthebathliftaftereachuse.SOLVENT-basedcleaners,such
as white spirit, should NOT be used.
i) To
disinfectthebathlift,useasoftbrushorclothandwipedownwithasterilizingsolutionor
anti-bacterialcleaner.Rinsetheproductwithcleanwater,thenwipeanddryusingacleancloth.
ii) Bath/medicinaloilsandothersolutionsareeasilyremovedwithwashing-upliquid.Donotallow
oilsorotheradditivestobuildup.Theyshouldberemovedfrequentlyotherwise,overthecourse
oftime,theymayleadtodegradationofthesuctionfeetand/ordiscolorationofthebathlift.
bathliftcanbecleanedinanautomatedwashingmachine(toamaximumtemperatureof
iii) The
73°C/163°Ffor3minutes),howeverthebatteryMUSTberemovedandwashedbyhand.The
batterymustnotbesubjectedtohightemperaturecleaning.
iv) Do
notcleanorrinsetheactuatorunderaconstantflowofwater,e.g.runningfaucet,ortotally
submergeitinwater.
v) If yourbathliftisfittedwithsoftcovers,ensureyouremovethemonaregularbasistocleanthe
bath lift surfaces.
Itisalsoadvisabletocleanthetubsurfaceunderthesuctionfeetfromtimetotime.
*Cleaningagentsshouldbeusedinaccordancewiththeirmanufacturer’sguidelines.
NOTE:
Iftheactuatorisdetachedfromthebathliftforcleaning,ensurethebatteryisalways
disconnectedfromthehandcontrol.
10. Maintenance and servicing
RepairsandservicingmustbeentrustedtoaLumex®Splashauthorizeddealerorengineer.
ThebathliftshouldbeinspectedannuallybyaLumex®Splashauthorizeddealerorengineer,who
willcheckthattherearenoloosefittingsoranyotherevidenceofmechanicaldamage.
Intended life - bath lift
ThedurabilityofthebathlifthasbeentestedinaccordancewithBSEN10535:2006(Hoistsforthe
transferofdisabledpersons-requirementsandtestmethods). If serviced and used in accordance
withtheoperatinginstructions,thebathliftandallparts(excludingbattery)willachieve11,000
liftingcyclesor5years’use,whicheveristhesoonest.
Intended life - battery
It is essential that the operating instructions with regards to battery use and charging is adhered
to.Thebatterylifeexpectancyis500chargecyclesor1year’suse,whicheveristhesoonest.We
recommendthebatterybereplacedaccordinglyinordertoobtainthebestperformancefromyour
bath lift.
11
11. Warranty
Thisproductissoldwiththebenefitthat,intheeventofanydefectofmanufactureormaterial
appearingwithin1yearofthedateofreceiptoftheproduct,thedefectwillberectifiedfreeof
charge, provided that:
i) Reasonable
evidenceisprovided(e.g.purchaseinvoiceordeliverynote)thattheproductwas
purchasednotmorethan1yearpriortothedateofclaim;and
ii) The
defectisnotattributabletoaccidentaldamage(eitherintransitorotherwise),fairwearand
tear,willfuldamage,misuseorunauthorizedrepair.
Thebatteryisalsoguaranteedfor1yeartopower(whenfullycharged)onebathingcycle*atfull
load (20stone/127kg/280lbs).
Consumers’statutoryrightsarenotaffected.
* The bathing cycle:
Foronebath,itisassumedthatthebathliftwillberaisedfromthebottomtotheheightofthetub
andthenloweredintothewatersupportingapersonofupto20stone/127kg/280lbs.Afterbathing,
the bath lift will raise the person to the height of the tub then the seat will be lowered tothebottom
of the tub for storage.
12. Symbols
Tocomplywithinternationalstandardsformedicalequipment,thefollowingsymbolsarefound
onthebathlift’slabels:
Symbol
Explanation
Onlydirectcurrentfromasmallbatteryisusedtopoweryourbathlift.ThereisNO
connectiontoelectricityfromanoutletwheninuse,sothereisnoriskofelectricshock.
ThebathliftiscategorizedastypeBmedicalequipmentandmeetsinternationalstandards
for electrical safety.
IP66
Thebathliftissealedtotheinternationalstandardsagainsttheeffectsofwaterspray.
IP67
Thebatteryissealedtotheinternationalstandardsagainsttheeffectsofimmersionin
watertoadepthof1metre/3.28ft3.
IP68
Thehandcontrolisprotectedagainstlongperiodsofimmersioninwaterunderpressure.
Thissymbolisfoundonthehandcontrolandmeansthelightrepresentsthebatterystatus.
PLEASEREADTHEINSTRUCTIONSBEFOREINSTALLATIONORUSE.
Donotbin/dispose.
Serialnumber.
Re-ordernumber.
12
Symbol
Explanation
Maximumload-liftingcapacity(person).
Caution!Surfacehottotouch.
13. Technical data
Thebathliftseatandbaseismadeofglass-filledpolypropylene.Thebaseframetubesaremade
ofaluminum.ThehandcontrolandbatteryaremadeofABS.Thehandcontrolbuttoncoverand
suctionfeetaremadeofthermoplasticelastomer.
Thebathliftisintheofficialcategoryof“internallypoweredequipment”andisnotsuitableforusein
thepresenceofflammableanaestheticmixturewithairornitrousoxide.
Theequipmentistestedinaccordancewith:
•BSEN10535:2006
•BSEN60601-1:2006
•TheEuropeanCouncilDirective93/42/EECrelatingtoMedicalDevices
ThebathliftcomplieswiththeWEEEdirective.
DISPOSAL: Theplastic,metalparts,packagingmaterialsandsuctionfeetarerecyclablebutthe
NickelMetalHydride(NiMH)battery,shouldbedisposedofonlybyreturningittoyoursupplier,
themanufactureroranauthorizeddisposalpoint.
175mm/6.89in
330mm/12.99in
175mm/6.89in
510mm/20.08in
340mm/13.39in
580mm/22.83in
Overallseatwidth-350mm/13.78in.
13
Bath Lift
Liftingcapacity(person)
127kg/20stone/280lbs
Netweight(excludingbattery)
6.5kg/14.33lbs
SeatheightUP
460mm/18.11in
SeatheightDOWN(loaded)
70mm/2.76in
Powerinput
14.4Vdcnominal7Amax
Dutycycle
Notmorethanonebathper15minutes
Degreeofprotection
IP66
Hand Control (Battery)
Input
14.4Vdcnominal1.0A
Output
14.4Vdcnominal7Amax
Degreeofprotection
IP68
Battery
IP67
Battery Charger
Input
100-240Vac50-60Hz1.0A
Output
14.4Vdcnominal1.0A
Operating and charging
Temperatures
Shipping and storage
Weight(packaged)
9kg/19.84lbs
0.12m3/4.24ft3
Max
40°C(104°F)
Shippingvolume
Min
0°C(32°F)
Temperatures
Max
40°C(104°F)
Min
-10°C(14°F)
Humidity
Max
90%RH
Min
10%RH
Pressure
Max
125kPa(18.4psi)
Min
73kPa(10.7psi)
This product is suitable for transport in
pressurized aircraft holds.
14
14. Troubleshooting
Symptom
Possible Cause
Solution
Section
Bath lift does not
move. No sound
from the motor.
•Batteryisflat.
•Chargebattery.
Section2
•Batteryisnot
connected to hand
control.
•Notpressingcorrect
area on hand
control buttons.
•Faultyelectronicsin
hand control.
•Batteryfault.
•Insertbatterycorrectlyintobothtracks Section5
on hand control cradle and slide all the
waytotheenduntilitclicks.
•PressarrowheadoneitherUPorDOWN Section5
buttons. Continue to press.
•Actuatorfault.
Red light on hand
control is on and
bath lift only
moves up.
Red light on hand
control is on but
bath lift does not
move.
•Batteryisflator
has not been fully
chargedandStop
Descent™hasbeen
activated to prevent
the bath lift lowering.
•Batteryisflatandhas
not been charged for
long period (typically
7-10days).
•Batteryfault.
•Contactsupplierorauthorizedservice/
repair center.
•Contactsupplierorauthorizedservice/
repaircenter.Replacebattery.
•Contactsupplierorauthorizedservice/
repair center.
•Chargebatteryimmediately.
•Chargebatteryimmediately.
•Chargebatterybeforeuseifbathlifthas
not been used for long periods (typically
7-10days).
•DoNOTstartbathwithREDlighton
handcontrol.Chargeimmediately.
•Ensurebatteryisplacedonchargeas
soonasyoufinishyourbathifFLASHING
GREENlightappearsonhandcontrol.
•Whenbathliftisnotinuse,leavebattery
connectedtohandcontrol.Disconnect
onlyforchargingorwhenmovingbathlift.
•Itisrecommendedthebatterybecharged
after each bath, wherever possible.
•Contactsupplierorauthorizedservice/
repair center.
n/a
n/a
n/a
Section2
Section2/
Section
5&
Section7
n/a
15
Symptom
Bath lift
only moves
intermittently.
Possible Cause
Solution
•Batteryisnotfully •Chargebattery.
charged.
•Excessiveuserload. •Donotusebathliftifyouweighover
20st/127kg/280lbs.
•Lowerbathlift,pullflapsfreefrom
•Bathlifthas
obstruction,thenresumelifting
encountered
operation.
obstruction during
lifting, e.g. integral •Contactyoursupplierforoptionalside
flapprotectorsandfittoanyintegraltub
tub handles, soap
handles.
dish.
•Ensurechargerplugisconnectedto
•Powertocharger
Battery does
powersocket/outletandswitchon
is not switched on
not appear to be
(ifapplicable).Checkforlightindicator
or charger is not
charged.
connected to power onchargerbox.
socket/outlet.
•Insertbatterycorrectlyintobothtracks
•Batteryisnot
connected correctly on charging cradle and slide all the way
totheenduntilitclicks.
to charging cradle.
•Ensure battery is disconnected from
•Batteryhas
charging cradle when the outlet
discharged before
is switched off or when charger is
use.
removed from socket/outlet.
•Chargebatteryafterlongperiodsof
non-use(typically7-10days).
•Checkforchargerindicatorlightsat
•Interruptionto
alternativepowersocket/outlet.
power supply or
faultysocket/outlet. •Checkifotherelectricalappliances
areworking.
•Chargerfault.
•Contactsupplierorauthorizedservice/
repair center.
•Batteryfault.
•Contactsupplierorauthorizedservice/
repair center.
•Insertbatterycorrectlyintobothtracks
Charger is plugged •Batteryisnot
into power socket/ connected correctly on charging cradle and slide all the way
totheenduntilitclicks.
to charging cradle.
outlet but charger
indicator lights do •Chargerfault.
•Contactsupplierorauthorizedservice/
not appear.
repair center.
16
Section
Section2
Section13
Section
6&
Section
15
Section2
Section2
Section2
n/a
n/a
n/a
Section2
n/a
Symptom
No lights appear
on hand control
when buttons are
pressed.
Possible Cause
•Batteryisnot
connected correctly
to hand control.
•Faultyelectronicsin
hand control.
•Frontsuctionfeet
Suction feet will
not stick to the tub are located over
rippled surfaces.
surface.
•Suctionfeetare
located on very
curved surfaces.
•Tubsurfaceisdirty/
dustyorenamelis
worn.
•Suctionfeetareold
ordamaged.
•Bathliftnotstored
Bath lift tips
properly after bath.
backwards in
highest position.
•Frontsuctionfeet
are located over
rippled tub surface.
•Suctionfeetare
located on very
curved surfaces.
•Suctionfeetnot
stickingtodirty/
dusty tub surface or
wornenamel.
•Oldordamaged
suction feet will not
sticktotubsurface.
Solution
Section
•Insertbatterycorrectlyintobothtracks Section5
on hand control and slide all the way to
theenduntilitclicks.
•Contactsupplierorauthorizedservice/ n/a
repair center.
•Donotusebathlift.
Section3
•Positionsuctionfeetonflattersurface
of tub.
Section4
•Cleantubsurfaceandunderneath
suction feet before installing bath lift.
Section3
•Contactsupplierorauthorizedservice/ n/a
repaircenterforreplacements.
•Alwayslowerbathlifttobottomoftub Section7
afteruse.(Checksuctionfeetsticktotub
beforeeachuse.)
•DONOTUSEbathlift.Rippledsurfaces Section3
prevent secure suction.
•Positionsuctionfeetonflattersurfaceof Section4
tub.DONOTUSEiffrontsuctionfeetdo
notsticktocontouredtubsurface.
Section3
•Cleantubsurfaceandunderneath
suction feet before pressing all 4 suction
feetfirmlyontotub.
•Contactsupplierorauthorizedservice/
repaircenterforreplacements.
n/a
17
15. Accessories
Thebathliftcanbesuppliedwitharangeofoptionalaccessories:
Accessory
Part No.
Soft cover set (back and seat)
5033A-BB3103
Providesevengreatercomfort.
Accessory
Part No.
Side flap protector
5033A-AB283
Sideflapprotectorsareavailableshouldyourbathliftnotsit
farbackenoughinthetubtoavoidintegralhandles.Supplied
individually,theprotectorhooksontoatubhandletoprevent
sideflapfromcatchingwhenraisingthebathlift.Internal
hooksectionisuniquelycoatedwithslip-resistantrubberto
limitmovementalonghandle.
Accessory
Part No.
Side flap protector extension kit
5033A-AB284
Comprises1sideflapprotectorand2clips.Byattaching
oneormoresideflapprotectorstogether,awiderside
flapprotectorcanbeformedoveranintegraltubhandle.
Thislimitsthepossibilityofmovementalongthehandleor
incorrectpositioning.Useseveralkitstoattachasmanyside
flapprotectorsasrequiredtofitthehandlelength.
18
Accessory
Part No.
Side flap protector extension kit
5033A-AB287
(non- hooking)
Comprises1non-hookingsideflapprotectorand2clips.Where
astandardsideflapprotectorcannotbemovedfurtheralongan
integral tub handle to enable the side flap to rest substantially
overit,thiskitenablesanadditionalsideflapprotectortobe
attachedbeyondtheendofthetubhandle.Thisprovidesa
substantialsurfaceareaforthesideflaptoglidesmoothlyover
thetubhandle.Useseveralkitstoattachasmanysideflap
protectorsasrequiredbeyondthetubhandle.
Accessory
Part No.
Extended suction feet set
5033A-BB3100
Raisesthebathliftby25mm/1inchtoenabletheseatandside
flap to reach level with the height of deep tubs.
19
16. Parts List
Item No.
Description
Part no.
Item No. Description
Part no.
1
LeftSideFlap
5033A-BB3002L
11
Actuator
5033A-BB3004
2
Seat
5033A-BB3001
12
5033A-AB105
3
RightSideFlap
5033A-BB3002R
4
SideFlapHingewithScrew 5033A-A167
13
5
SmartChargerNiMH(US)
5033A-CU-3001
HandControlNiMH
CompleteBaseFrame(No
SuctionFeet)
BaseFrameTubeEndCap
6
Battery
5033A-A230
7
SuctionFoot
5033A-BB3504
8
ActuatorLockingPin
5033A-BB3107
9
ActuatorClamp
M6x12mm(0.47in)Long
SocketButtonScrew(x4)
5033A-BB3003
10
14
15
5033A-BB3007
5033A-BB3009
ActuatorSnapPin
5033A-AB003
SuctionFootRemovalTool
5033A-BB3901
(notshown)
SuctionFeet(Setof4)with
5033A-BB3504S
RemovalTool(notshown)
5033A-TL539
2
15
1
4
14
13
3
5
12
11
7
8
10
6
9
7
MountwayLimitedreservestherighttoalterspecificationstoproductsorpackagingatanytime.
20
-
-I
-
1­
-
-I
-
1­
IREF I ML3 BB1 5033A
© Mountway Limited 2011
01: 10111
Manufactured for: GF Healt h Pro ducts, Inc.
293 5 Northeast Pa rkway
At lanta, GA 30360
www.grahamfield.com
SplashTM is a trademark of Mountway Ltd.
CE
----
Lumex• is a registered trademark of GF Health Product s, Inc.
()
......
IN"\1:STO R IN l"l!Ol'U: