owners manual - PGF Personal Golf Fan

One (1) Year Limited Warranty
Register your PGF Fan at golfcartfan.com to activate your warranty.
This requires the serial number found on the bottom of the fan by the battery door.
OWNERS MANUAL
Service Instructions:
DO NOT attempt to repair or modify any mechanical or electrical parts of this fan. Doing so will
VOID this warranty.
1. This warranty applies Only to the original owner of the PGF.
2. This warranty Only applies to the repair or replacement of any of the
manufactured parts of the PGF. Cynwark Corp reserves the right to determine
if repair or replacement is warranted.
3. Operating the PGF under conditions or usage not specified in the warnings,
instructions, or care directions, or attempts to repair or modify the fan in
anyway will render this warranty void.
4. Unless other wise prescribed by law, Cynwark Corp will not be liable for any
personal injury, property or incidental or consequential damage of any kind
(including water damage) resulting from defects, malfunctions, defects, improper
installation or alterations of this product.
5. All parts of the PGF are guaranteed for a period of one (1) year from the date
of purchase.
6. If you experience any other problem or claim with the PGF, please call or
contact our customer service department at 888-938-6672.
Return Instructions:
Please follow the directions below when initiating a Warranty Return:
1. Please pack the PGF in its original carton or other carton and packing materials
to insure no damage occurs in shipping
2. Please include your full name, address with Zip code and telephone number.
3. Please include a copy of your original sales receipt or Proof of Purchase.
4. Provide a summary of the defect or problem that is occurring with the PGF.
5. All shipping charges to be paid by the sender.
6. Call 888-938-6672 for return authorization.
This warranty gives you specific legal rights and you may have other rights that vary from state to state. The
provisions of this Warranty are in addition to and not a modification of, or subtraction from the statutory
warranties and other rights or remedies contained in any applicable legislation. To the extent that any provision of
this Warranty is inconsistent with any applicable law, such provision shall be deemed voided or amended as
necessary to comply with such law.
TM
patented
personal golf fan
Cynwark Corporation
433 Northpark Central Drive
Houston, TX 77073
888-938-6672
Cynwark Corporation 433 Northpark Central Drive Houston, TX 77073 888-938-6672
Copyright © 2013 CYNWARK Corporation
www.PGFfan.com
www.golfcartfan.com
888-938-6672
Congratulations on the purchase of your Personal Golf Fan.
Important Safety Instructions
The Personal Golf Fan is designed to operate in a golf cart cup holder. The Personal Golf
Fan, like all special electronic devices should be handled with care and not dropped.
USE CAUTION: This fan is very powerful. Operating the fan while it is standing on a flat
surface, with a cup adapter installed, could cause the fan to blow over!
We are pleased to announce the PGF Personal Golf Fan
was the recipient of the 2013 PGA Inventor’s Spotlight
BEFORE CHARGING THE BATTERY OR USING THE FAN PLEASE READ ALL
INSTRUCTIONS AND PRECAUTIONS IN THIS MANUAL.
USE ONLY THE CHARGER SUPPLIED WITH YOUR PGF FAN.
DO NOT RUN FAN WHILE CHARGING.
This manual lists the main features along with how to operate and properly maintain the PGF.
Take care of your PGF and it will give you years of comfortable Golf.
Main Features
When using an electrical appliance, basic precautions should always be observed, including
the following:
1.
High air flow for outdoor use. Feels like a 20 MPH wind!
DO NOT rely exclusively upon the safety devices built into this unit.
2.
Approximate run time of 6½ hrs. on normal speed and 3¾ hrs. on high speed
with fully charged battery
DO NOT insert anything into the fan shroud. This includes tools
such as screwdrivers or body parts such as fingers, toes or tongues.
3.
Battery charge time is under 3 hrs., if completely discharged.
Caution should be used when operated around small children.
4.
High efficiency, high power, ball bearing, long lasting brushless motor.
5.
New chemistry Lithium-Ion battery, will not lose charge over time.
6.
Portable and designed to fit in 5 different golf carts.
7.
Overall height is 19 inches and has a weight of 2 lbs.
8.
Battery and charger have built in safety circuits.
9.
10.
Fan blade winglets to increase airflow.
Includes water resistant carry bag and quick cover raincoat.
11.
(1) Year Warranty
PGF is a trademark of Cynwark Corporation
DO NOT expose the fan directly to rain or wet conditions. Treat the fan as you
would any other electronic device, such as a cell phone or radio.
DO NOT use the battery charger outdoors and do not expose it to wet or
damp conditions.
DO NOT disassemble, incinerate or pierce the battery with any sharp object.
DISPOSAL: The lithium-ion (NMC) battery in this fan is generally considered to be
landfill safe. Check local regulations for disposal.
Copyright © 2013 CYNWARK Corporation
www.PGFfan.com
www.golfcartfan.com
888-938-6672
Motor Housing
Brushless Ball Bearing Motor
The shorter Cup Adapter will fit in the E-Z-Go golf cart TXT and RXV models. The RXV
will require the usage of the supplied Black Polymer ring to insure a snug fit in the cup
holder.
TM
personal golf fan
The taller Cup Adapter will fit in the Club Car Precedent, Club Car DS, and Yamaha golf
carts. The Yamaha will require the usage of the supplied Red Polymer ring to insure a snug
fit in the cup holder.
Thumb Screw for Angle Adjustment
Rechargable Lithium-Ion
Battery Pack
Power Switch
Push Once for Low/Normal
Second push for High
Third push for Off
Cup Adapter
Easily screws on and off
Short Cup Adapter for:
• E-Z-Go TXT
• E-Z-Go RXV (with Black Polymer Ring)
Assembly
1. Remove the cup adapter by twisting
counter clockwise as viewed from the top.
2. Using a Phillips screw driver remove the
screw on the battery door cover.
3. The connection from the battery to the
motor is a one way plug. Be sure to align the
plug so that the corresponding red and black
wires line up.Then slide battery into housing.
4. To remove the battery just reverse the
process.
Copyright © 2013 CYNWARK Corporation
The Polymer rings can be stored inside the Cup Adapters. The Polymer rings are not toys
and should be kept away from children and pets to avoid choking.
Tall Cup Adapter for:
• Club Car Precedent
• Club Car DS
• Yamaha (with Red Polymer Ring)
Charging Port
PGF battery Installation and Removal
PGF Cup Adapters
The fan is supplied with two screw on Cup Adapters. Each of the Adapters is marked with
the name of the golf cart for which it is most suited.
Operation
The power switch is a soft rectangular push button directly above the charge receptacle.
Push the power switch once for low speed; push a second time for high speed and a third
time for off.
To adjust the position of the fan head; loosen the thumb screw, adjust the fan head position
and retightened the thumb screw. Do not over tighten the thumb screw
www.PGFfan.com
www.golfcartfan.com
888-938-6672
Charging The Battery
Charge the battery in a cool, dry place. Charging should be done with the fan off. The battery does not
have to be fully discharged before recharging. The battery will not develop a memory.
Approximate charge time is under 3 hrs. if battery is completely discharged. The battery can be stored
fully charged. Unlike other battery types, it will maintain charge almost indefinitely.
1. Plug the charger into an AC wall outlet.The LED on the front of the charger will illuminate green.
2. Plug the charger output into the charging receptacle on the fan.
3. The LED on the charger will switch to red indicating that the battery is charging.
4. Once the battery is fully charged the LED on the charger will turn green.
5. Unplug the charger from the fan and the wall socket. The safety circuits in the charger and the
battery will discontinue the charge once the battery is fully charged. It is not recommended to
rely solely on the safety circuits.
6. Unplug the charger when not in use.
NOTE: Lithium-Ion batteries, while in use, will continue to provide full power with very little power
fade unlike typical batteries.When the battery is fully discharged, the battery safety circuits will immediately
cut power to the fan motor. The battery circuits will not allow the fan to run until the battery has been
recharged.
NOTE: The fan may start running when the charger is plugged in. This can occur if the battery was cut
off by the discharge safety circuits and the power switch is left in a run position. Push the power button
until the fan stops and then continue charging the battery.
NOTE: For optimum performance, the battery should have one charge/discharge cycle every three
months.
NOTE: The PGF should only be charged on a non-flammable surface. Your PGF is provided with an
engineered charger and only this charger should be used. If you should lose the PGF charger additional
chargers are available for sale on our Web Site.
Charging Indicator Light
Red when charging
Green when fully charged
Copyright © 2013 CYNWARK Corporation
Care & Cleaning
Make sure the fan is turned off before cleaning. Clean parts with a duster or damp cloth.
Use care around the motor housing to prevent liquid from coming in contact with motor.
Prior to resuming use, make sure the PGF is dry and all moisture has been eliminated. Do
not immerse the PGF in any type of liquid or use abrasive cleaning solutions. When storing
the PGF in the off season, make sure it is in a dry environment.
Specifications *
Motor
Motor Speed
Approximate Charge Time (Battery fully discharged)
Approximate Run Time (Battery fully charged)
Battery
Battery Charger Input
Battery Charger Maximum Output
Overall Height
Overall Weight
Brushless; ball bearing; 12V DC
5000 RPM under load
Under 3 hours
3¾ hours on high speed, 6½ hours on low speed
11.1 V; 4.4 amp hour; lithium-ion (NMC)
100–240V; 50/60 Hz; 0.4A
12.6V DC; 2A
19 inches
2 lbs.
*All specifications are based on the latest product information available at the time of
printing. We reserve the right to make changes at any time without notice.
This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause
harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired
operation. Note: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of
the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This
equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may
cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the
equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.
www.PGFfan.com
www.golfcartfan.com
888-938-6672
One (1) Year Limited Warranty
Register your PGF Fan at PGFfan.com to activate your warranty.
This requires the serial number found on the bottom of the fan by the battery door.
OWNERS MANUAL
Service Instructions:
DO NOT attempt to repair or modify any mechanical or electrical parts of this fan. Doing so will
VOID this warranty.
1. This warranty applies Only to the original owner of the PGF.
2. This warranty Only applies to the repair or replacement of any of the
manufactured parts of the PGF. Cynwark Corp reserves the right to determine
if repair or replacement is warranted.
3. Operating the PGF under conditions or usage not specified in the warnings,
instructions, or care directions, or attempts to repair or modify the fan in
anyway will render this warranty void.
4. Unless other wise prescribed by law, Cynwark Corp will not be liable for any
personal injury, property or incidental or consequential damage of any kind
(including water damage) resulting from defects, malfunctions, defects, improper
installation or alterations of this product.
5. All parts of the PGF are guaranteed for a period of one (1) year from the date
of purchase.
6. If you experience any other problem or claim with the PGF, please call or
contact our customer service department at 888-938-6672.
Return Instructions:
Please follow the directions below when initiating a Warranty Return:
1. Please pack the PGF in its original carton or other carton and packing materials
to insure no damage occurs in shipping
2. Please include your full name, address with Zip code and telephone number.
3. Please include a copy of your original sales receipt or Proof of Purchase.
4. Provide a summary of the defect or problem that is occurring with the PGF.
5. All shipping charges to be paid by the sender.
6. Call 888-938-6672 for return authorization.
This warranty gives you specific legal rights and you may have other rights that vary from state to state. The
provisions of this Warranty are in addition to and not a modification of, or subtraction from the statutory
warranties and other rights or remedies contained in any applicable legislation. To the extent that any provision of
this Warranty is inconsistent with any applicable law, such provision shall be deemed voided or amended as
necessary to comply with such law.
TM
patented
personal golf fan
Cynwark Corporation
433 Northpark Central Drive
Houston, TX 77073
888-938-6672
Cynwark Corporation 433 Northpark Central Drive Houston, TX 77073 888-938-6672
Copyright © 2013 CYNWARK Corporation
www.PGFfan.com
www.golfcartfan.com
888-938-6672