2.4.a Electrical Drawings DSI System IFC

Transcription

OWENSBORO MUNICIPAL UTILITIES
ELMER SMITH STATION - UNIT 2
OWENSBORO, KY
DSI SYSTEM
NOL-TEC JOB 9190A
NOL-TEC SYSTEMS INC.
CONTROL SYSTEM
SYSTEM LETTERS COVERED UNDER THIS DRAWING PACKAGE
COVER SHEET
SYSTEM LETTER
JOB NUMBER
A
4639
DESCRIPTION OF THE SYSTEM
OMU - ELMER SMITH STATION - UNIT 2 DSI
OWENSBORO, KY
DSI SYSTEM
0
01JUN15
REV
DATE
ISSUED FOR CONSTRUCTION
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4001
- EMERGENCY STOP PUSH BUTTON
NOTES & SYMBOLS
- SELECTOR SWITCH
- NORMALLY OPEN PUSH BUTTON
A - AMP
CB - CIRCUIT BREAKER
- NORMALLY CLOSED PUSH BUTTON
CP - CONTROL PANEL
- ALARM HORN
CR - CONTROL RELAY
- PILOT LIGHT
A
B
C
G
= AMBER
= BLUE
= CLEAR
= GREEN
ES - EMERGENCY STOP PUSH BUTTON
R = RED
W = WHITE
Y = YELLOW
FLA - FULL LOAD AMPS
FS - FLOW SWITCH
FU - FUSE
- CIRCUIT BREAKER
GND - GROUND
HP - HORSEPOWER
- FUSE
JB - JUNCTION BOX
- CONTROL RELAY / MOTOR STARTER
LSHH - LEVEL CONTROL EMERGENCY HIGH
LSH - LEVEL CONTROL HIGH
DUST
FLTR
- DUST FILTER TIMER BOARD
TMR BRD
LSM - LEVEL CONTROL MID
- ZERO SPEED SWITCH
WIRING NOTES:
- NORMALLY OPEN PROXIMITY SWITCH
- SOLENOID
- NORMALLY OPEN LIMIT SWICH
- NORMALLY CLOSED LIMIT SWITCH
- NORMALLY OPEN PRESSURE SWITCH
1)
2)
3)
4)
5)
6)
7)
8)
9)
10)
11)
12)
13)
14)
15)
LSL - LEVEL CONTROL LOW
ALL CONTROL WIRING TO BE RED 16 AWG MTW MINIMUM.
NEUTRAL TO BE WHITE 16 AWG MTW MINIMUM.
GROUND WIRING TO BE GREEN 16 AWG MTW MINIMUM.
DC WIRING TO BE BLUE 16 AWG MTW MINIMUM.
DC COMMON TO BE WHITE /w BLUE STRIPE 16 AWG MTW MINIMUM.
DUAL SOURCE VOLTAGES TO PANEL TO BE YELLOW 16 AWG MTW MINIMUM.
MOTOR WIRING TO BE BLACK 12 AWG MTW MINIMUM.
2-WIRE ANALOG CABLING TO BE BELDEN 8761 OR EQUIVALENT.
4-WIRE ANALOG CABLING TO BE BELDEN 8723 OR EQUIVALENT.
LOAD CELL SIGNAL CABLING TO BE 6 CONDUCTOR RICE LAKE SURVIVOR EL147HE OR EQUIVALENT.
C2 LOAD CELL SIGNAL CABLING TO BE 8 CONDUCTOR HARDY 6020-001/C2 CERTIFIED OR EQUIVALENT.
ALLEN BRADLEY CONTROL NET CABLE TO BE BELDEN 3092A COAX OR EQUIVALENT.
ETHERNET CABLING TO BE CAT 5e PLENUM RATED.
ALLEN BRADLEY DH+/RIO CABLING TO BE BELDEN 9463 (BLUE HOSE) OR EQUIVALENT.
SUPPLIED BY OTHERS.
MCR - MASTER CONTROL RELAY
MS - MOTOR STARTER
PB - PUSH BUTTON
PL - PILOT LIGHT
PSH - PRESSURE SWITCH HIGH
PSL - PRESSURE SWITCH LOW
PDS - PRESSURE DIFFERENTIAL SWITCH
PROX - PROXIMITY SWITCH
- NORMALLY CLOSED PRESSURE SWITCH
PT - PRESSURE TRANSDUCER
- NORMALLY OPEN CONTACT SWITCH
SS - SELECTOR SWITCH
- NORMALLY CLOSED CONTACT SWITCH
TS - TEMPERATURE SWITCH
TMR - TIMER SWITCH
- NORMALLY OPEN TIMER CONTACT SWITCH
DELAYED OPENING AFTER DE- ENERGIZED
VFD - VARIABLE FREQUENCY DRIVE
TERMINAL NOTES:
- NORMALLY CLOSED TIMER CONTACT SWITCH
DELAYED OPENING AFTER DE- ENERGIZED
XV - SOLENOID
-DENOTES TERMINALS IN CONTROL ENCLOSURE.
ZSO - LIMIT SWITCH OPEN
-DENOTES TERMINALS LOCATED IN REMOTE JUNCTION ENCLOSURE.
- NORMALLY OPEN TIMER CONTACT SWITCH
DELAYED OPENING AFTER ENERGIZED
-DENOTES FIELD WIRING TO BE COMPLETED BY OTHERS.
ZSC - LIMIT SWITCH CLOSED
-DENOTES WIRING COMPLETED BY NOL-TEC SYSTEMS INC.
ZSS - ZERO SPEED SWITCH
- NORMALLY CLOSED TIMER CONTACT SWITCH
DELAYED OPENING AFTER ENERGIZED
- NORMALLY OPEN TEMPERATURE SWITCH
XXX-XX -FIRST 3 DIGITS EQUALS THE PAGE & THE NEXT 2 DIGITS EQUALS THE ROW.
EXAMPLE: 015-06 WHERE 015 IS THE PAGE AND 06 IS THE ROW ON THAT PAGE.
AUX01506
COIL ID
- NORMALLY CLOSED TEMPERATURE SWITCH
XXX-XX
COIL LOCATION
- NORMALLY OPEN FLOW SWITCH
- NORMALLY CLOSED FLOW SWITCH
- GROUND
- PLUG/CORD CONNECTION
CONTROL SYSTEM
NOTES & SYMBOLS
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4002
DRAWING NUMBER
DESCRIPTION
DRAWING NUMBER
DESCRIPTION
9190A-7 - 4001
CONTROL SYSTEM - COVER SHEET
9190A-7 - 4052
9190A-7 - 4002
CONTROL SYSTEM - NOTES & SYMBOLS
9190A-7 - 4053
A-PDP4050 CONTROL DISTRIBUTION PANEL - BILL OF MATERIAL
A-PDP4050 CONTROL DISTRIBUTION PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4003
CONTROL SYSTEM - DRAWING INDEX
9190A-7 - 4054
SPARE DRAWING
9190A-7 - 4004
9190A-7 - 4055
A-PDP4050 CONTROL DISTRIBUTION PANEL - WIRING DIAGRAM
9190A-7 - 4005
9190A-7 - 4056
SPARE DRAWING
9190A-7 - 4006
SPARE DRAWING
9190A-7 - 4057
SPARE DRAWING
9190A-7 - 4007
SPARE DRAWING
9190A-7 - 4058
SPARE DRAWING
9190A-7 - 4008
CONTROL SYSTEM - SYSTEM ARCHITECTURE
9190A-7 - 4059
SPARE DRAWING
9190A-7 - 4009
CONTROL SYSTEM - COMMUNICATIONS ARCHITECTURE
9190A-7 - 4060
A-XFMR4060 15KVA HEAT TRACE TRANSFORMER - LAYOUT
9190A-7 - 4010
CONTROL SYSTEM - ONE-LINE DIAGRAM
9190A-7 - 4061
A-XFMR4060 15KVA HEAT TRACE TRANSFORMER - WIRING DIAGRAM
9190A-7 - 4011
CONTROL SYSTEM - ONE-LINE DIAGRAM
9190A-7 - 4062
SPARE DRAWING
9190A-7 - 4012
SPARE DRAWING
9190A-7 - 4063
SPARE DRAWING
9190A-7 - 4013
SPARE DRAWING
9190A-7 - 4064
SPARE DRAWING
9190A-7 - 4014
SPARE DRAWING
9190A-7 - 4065
SPARE DRAWING
9190A-7 - 4015
SPARE DRAWING
9190A-7 - 4066
SPARE DRAWING
9190A-7 - 4016
SPARE DRAWING
9190A-7 - 4067
SPARE DRAWING
9190A-7 - 4017
SPARE DRAWING
9190A-7 - 4068
SPARE DRAWING
9190A-7 - 4018
SPARE DRAWING
9190A-7 - 4069
SPARE DRAWING
9190A-7 - 4019
SPARE DRAWING
9190A-7 - 4070
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - PANEL LAYOUT
9190A-7 - 4020
A-PDP4020 480Y/277V DISTRIBUTION PANEL - PANEL LAYOUT
9190A-7 - 4071
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - BACKPANEL LAYOUT
9190A-7 - 4021
A-PDP4020 480Y/277V DISTRIBUTION PANEL - WIRING DIAGRAM
9190A-7 - 4072
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - BILL OF MATERIAL
9190A-7 - 4022
SPARE DRAWING
9190A-7 - 4073
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4023
SPARE DRAWING
9190A-7 - 4074
SPARE DRAWING
9190A-7 - 4024
SPARE DRAWING
9190A-7 - 4075
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - WIRING DIAGRAM
9190A-7 - 4025
SPARE DRAWING
9190A-7 - 4076
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL - WIRING DIAGRAM
9190A-7 - 4026
SPARE DRAWING
9190A-7 - 4077
SPARE DRAWING
9190A-7 - 4027
SPARE DRAWING
9190A-7 - 4078
SPARE DRAWING
9190A-7 - 4028
SPARE DRAWING
9190A-7 - 4079
SPARE DRAWING
9190A-7 - 4029
SPARE DRAWING
9190A-7 - 4080
A-CP4080 LIGHTING CONTROL PANEL - PANEL LAYOUT
9190A-7 - 4030
A-XFMR4030 45KVA UTILITY TRANSFORMER - LAYOUT
9190A-7 - 4081
A-CP4080 LIGHTING CONTROL PANEL - WIRING DIAGRAM
9190A-7 - 4031
A-XFMR4030 45KVA UTILITY TRANSFORMER - WIRING DIAGRAM
9190A-7 - 4082
SPARE DRAWING
9190A-7 - 4032
SPARE DRAWING
9190A-7 - 4083
SPARE DRAWING
9190A-7 - 4033
SPARE DRAWING
9190A-7 - 4084
SPARE DRAWING
9190A-7 - 4034
SPARE DRAWING
9190A-7 - 4085
SPARE DRAWING
9190A-7 - 4035
A-PDP4035 UTILITY DISTRIBUTION PANEL - PANEL LAYOUT
9190A-7 - 4086
SPARE DRAWING
9190A-7 - 4036
A-PDP4035 UTILITY DISTRIBUTION PANEL - WIRING DIAGRAM
9190A-7 - 4087
SPARE DRAWING
9190A-7 - 4037
SPARE DRAWING
9190A-7 - 4088
SPARE DRAWING
9190A-7 - 4038
SPARE DRAWING
9190A-7 - 4089
SPARE DRAWING
9190A-7 - 4039
SPARE DRAWING
9190A-7 - 4090
SPARE DRAWING
9190A-7 - 4040
A-XFMR4040 30KVA CONTROL TRANSFORMER - LAYOUT
9190A-7 - 4091
SPARE DRAWING
9190A-7 - 4041
A-XFMR4040 30KVA CONTROL TRANSFORMER - WIRING DIAGRAM
9190A-7 - 4092
SPARE DRAWING
9190A-7 - 4042
SPARE DRAWING
9190A-7 - 4093
SPARE DRAWING
9190A-7 - 4043
SPARE DRAWING
9190A-7 - 4094
SPARE DRAWING
9190A-7 - 4044
SPARE DRAWING
9190A-7 - 4095
SPARE DRAWING
9190A-7 - 4045
SPARE DRAWING
9190A-7 - 4096
SPARE DRAWING
9190A-7 - 4046
SPARE DRAWING
9190A-7 - 4097
SPARE DRAWING
9190A-7 - 4047
SPARE DRAWING
9190A-7 - 4098
SPARE DRAWING
9190A-7 - 4048
SPARE DRAWING
9190A-7 - 4099
SPARE DRAWING
9190A-7 - 4049
SPARE DRAWING
9190A-7 - 4050
A-PDP4050 CONTROL DISTRIBUTION PANEL - PANEL & BACKPANEL LAYOUT
9190A-7 - 4051
SPARE DRAWING
CONTROL SYSTEM
DRAWING INDEX
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4003
DRAWING NUMBER
DESCRIPTION
DRAWING NUMBER
DESCRIPTION
9190A-7 - 4100
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - PANEL LAYOUT
9190A-7 - 4152
SPARE DRAWING
9190A-7 - 4101
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - BACKPANEL LAYOUT
9190A-7 - 4153
SPARE DRAWING
9190A-7 - 4102
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - BILL OF MATERIAL
9190A-7 - 4154
SPARE DRAWING
9190A-7 - 4103
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4155
SPARE DRAWING
9190A-7 - 4104
SPARE DRAWING
9190A-7 - 4156
SPARE DRAWING
9190A-7 - 4105
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - 480VAC POWER DISTRIBUTION
9190A-7 - 4157
SPARE DRAWING
9190A-7 - 4106
A-MCP4100 TRUCK UNLOAD MOTOR CONTROL PANEL - 120VAC POWER DISTRIBUTION
9190A-7 - 4158
SPARE DRAWING
9190A-7 - 4107
SPARE DRAWING
9190A-7 - 4159
SPARE DRAWING
9190A-7 - 4108
SPARE DRAWING
9190A-7 - 4160
A-CP4160 TRUCK UNLOAD PANEL - PANEL LAYOUT
9190A-7 - 4109
SPARE DRAWING
9190A-7 - 4161
A-CP4160 TRUCK UNLOAD PANEL - BACKPANEL LAYOUT
9190A-7 - 4110
A-MCP4110 LINE 1 MOTOR CONTROL PANEL - PANEL LAYOUT
9190A-7 - 4162
A-CP4160 TRUCK UNLOAD PANEL - BILL OF MATERIAL
9190A-7 - 4111
A-MCP4110 LINE 1 MOTOR CONTROL PANEL - BACKPANEL LAYOUT
9190A-7 - 4163
A-CP4160 TRUCK UNLOAD PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4112
A-MCP4110 LINE 1 MOTOR CONTROL PANEL - BILL OF MATERIAL
9190A-7 - 4164
SPARE DRAWING
9190A-7 - 4113
A-MCP4110 LINE 1 MOTOR CONTROL PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4165
A-CP4160 TRUCK UNLOAD PANEL - 120VAC POWER DISTRIBUTION
9190A-7 - 4114
SPARE DRAWING
9190A-7 - 4166
SPARE DRAWING
9190A-7 - 4115
A-MCP4110 LINE 1 MOTOR CONTROL PANEL - 480VAC POWER DISTRIBUTION
9190A-7 - 4167
SPARE DRAWING
9190A-7 - 4116
9190A-7 - 4168
SPARE DRAWING
9190A-7 - 4117
9190A-7 - 4169
SPARE DRAWING
9190A-7 - 4118
9190A-7 - 4170
A-CP4170 SILO MARSHALLING CABINET - PANEL LAYOUT
9190A-7 - 4119
SPARE DRAWING
9190A-7 - 4171
A-CP4170 SILO MARSHALLING CABINET - BACKPANEL LAYOUT
9190A-7 - 4120
A-MCP4120 LINE 2 MOTOR CONTROL PANEL - PANEL LAYOUT
9190A-7 - 4172
A-CP4170 SILO MARSHALLING CABINET - BILL OF MATERIAL
9190A-7 - 4121
A-MCP4120 LINE 2 MOTOR CONTROL PANEL - BACKPANEL LAYOUT
9190A-7 - 4173
A-CP4170 SILO MARSHALLING CABINET - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4122
A-MCP4120 LINE 2 MOTOR CONTROL PANEL - BILL OF MATERIAL
9190A-7 - 4174
SPARE DRAWING
9190A-7 - 4123
A-MCP4120 LINE 2 MOTOR CONTROL PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4175
A-CP4170 SILO MARSHALLING CABINET - 120VAC & 24VDC POWER DISTRIBUTION
9190A-7 - 4124
SPARE DRAWING
9190A-7 - 4176
A-CP4170 SILO MARSHALLING CABINET - WIRING DIAGRAM
9190A-7 - 4125
9190A-7 - 4177
9190A-7 - 4126
9190A-7 - 4178
9190A-7 - 4127
9190A-7 - 4179
SPARE DRAWING
9190A-7 - 4128
9190A-7 - 4180
A-CP4180 SILO DUST COLLECTOR PANEL - PANEL LAYOUT
9190A-7 - 4129
SPARE DRAWING
9190A-7 - 4181
A-CP4180 SILO DUST COLLECTOR PANEL - BACKPANEL LAYOUT
9190A-7 - 4130
A-CP4130 MAIN PLC PANEL - PANEL LAYOUT
9190A-7 - 4182
A-CP4180 SILO DUST COLLECTOR PANEL - BILL OF MATERIAL
9190A-7 - 4131
A-CP4130 MAIN PLC PANEL - BACKPANEL LAYOUT
9190A-7 - 4183
A-CP4180 SILO DUST COLLECTOR PANEL - LEGENDS
9190A-7 - 4132
A-CP4130 MAIN PLC PANEL - BILL OF MATERIAL
9190A-7 - 4184
SPARE DRAWING
9190A-7 - 4133
A-CP4130 MAIN PLC PANEL - TERMINAL LAYOUT
9190A-7 - 4185
A-CP4180 SILO DUST COLLECTOR PANEL - WIRING DIAGRAM
9190A-7 - 4134
A-CP4130 MAIN PLC PANEL - LEGENDS
9190A-7 - 4186
SPARE DRAWING
9190A-7 - 4135
A-CP4130 MAIN PLC PANEL - 120VAC POWER DISTRIBUTION
9190A-7 - 4187
SPARE DRAWING
9190A-7 - 4136
A-CP4130 MAIN PLC PANEL - 24VDC POWER DISTRIBUTION
9190A-7 - 4188
SPARE DRAWING
9190A-7 - 4137
SPARE DRAWING
9190A-7 - 4189
SPARE DRAWING
9190A-7 - 4138
SPARE DRAWING
9190A-7 - 4190
A-JB4190 SILO PANT LEG JUNCTION BOX - PANEL & BACKPANEL LAYOUT
9190A-7 - 4139
SPARE DRAWING
9190A-7 - 4191
SPARE DRAWING
9190A-7 - 4140
A-CP4130 MAIN PLC PANEL - I/O WIRING DIAGRAM. RACK A SLOTS 0 & 1
9190A-7 - 4192
A-JB4190 SILO PANT LEG JUNCTION BOX - BILL OF MATERIAL
9190A-7 - 4141
9190A-7 - 4193
A-JB4190 SILO PANT LEG JUNCTION BOX - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4142
9190A-7 - 4194
SPARE DRAWING
9190A-7 - 4143
9190A-7 - 4195
A-JB4190 SILO PANT LEG JUNCTION BOX - WIRING DIAGRAM
9190A-7 - 4144
9190A-7 - 4196
SPARE DRAWING
9190A-7 - 4145
9190A-7 - 4197
SPARE DRAWING
9190A-7 - 4146
A-CP4130 MAIN PLC PANEL - I/O WIRING DIAGRAM. RACK A SLOT 12
9190A-7 - 4198
SPARE DRAWING
9190A-7 - 4147
A-CP4130 MAIN PLC PANEL - I/O WIRING DIAGRAM. RACK B SLOTS 0 & 1
9190A-7 - 4199
SPARE DRAWING
9190A-7 - 4148
9190A-7 - 4149
9190A-7 - 4150
CONTROL SYSTEM
DRAWING INDEX
9190A-7 - 4151
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4004
DRAWING NUMBER
DESCRIPTION
DRAWING NUMBER
DESCRIPTION
9190A-7 - 4200
A-JB4200 SCALE 1 JUNCTION BOX - PANEL & BACKPANEL LAYOUT
9190A-7 - 4252
A-CP4240 DUCT 2 REMOTE I/O PANEL - I/O WIRING DIAGRAM, RACK D SLOTS 4 & 5
9190A-7 - 4201
SPARE DRAWING
9190A-7 - 4253
9190A-7 - 4202
A-JB4200 SCALE 1 JUNCTION BOX - BILL OF MATERIAL
9190A-7 - 4254
SPARE DRAWING
9190A-7 - 4203
A-JB4200 SCALE 1 JUNCTION BOX - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4255
SPARE DRAWING
9190A-7 - 4204
SPARE DRAWING
9190A-7 - 4256
SPARE DRAWING
9190A-7 - 4205
A-JB4200 SCALE 1 JUNCTION BOX - WIRING DIAGRAM
9190A-7 - 4257
SPARE DRAWING
9190A-7 - 4206
SPARE DRAWING
9190A-7 - 4258
SPARE DRAWING
9190A-7 - 4207
SPARE DRAWING
9190A-7 - 4259
SPARE DRAWING
9190A-7 - 4208
SPARE DRAWING
9190A-7 - 4260
SPARE DRAWING
9190A-7 - 4209
SPARE DRAWING
9190A-7 - 4261
SPARE DRAWING
9190A-7 - 4210
A-JB4210 SCALE 2 JUNCTION BOX - PANEL & BACKPANEL LAYOUT
9190A-7 - 4262
SPARE DRAWING
9190A-7 - 4211
SPARE DRAWING
9190A-7 - 4263
SPARE DRAWING
9190A-7 - 4212
A-JB4210 SCALE 2 JUNCTION BOX - BILL OF MATERIAL
9190A-7 - 4264
SPARE DRAWING
9190A-7 - 4213
A-JB4210 SCALE 2 JUNCTION BOX - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4265
SPARE DRAWING
9190A-7 - 4214
SPARE DRAWING
9190A-7 - 4266
SPARE DRAWING
9190A-7 - 4215
A-JB4210 SCALE 2 JUNCTION BOX - WIRING DIAGRAM
9190A-7 - 4267
SPARE DRAWING
9190A-7 - 4216
SPARE DRAWING
9190A-7 - 4268
SPARE DRAWING
9190A-7 - 4217
SPARE DRAWING
9190A-7 - 4269
SPARE DRAWING
9190A-7 - 4218
SPARE DRAWING
9190A-7 - 4270
SPARE DRAWING
9190A-7 - 4219
SPARE DRAWING
9190A-7 - 4271
SPARE DRAWING
9190A-7 - 4220
A-CP4220 DUCT 1 REMOTE I/O PANEL - PANEL LAYOUT
9190A-7 - 4272
SPARE DRAWING
9190A-7 - 4221
A-CP4220 DUCT 1 REMOTE I/O PANEL - BACKPANEL LAYOUT
9190A-7 - 4273
SPARE DRAWING
9190A-7 - 4222
A-CP4220 DUCT 1 REMOTE I/O PANEL - BILL OF MATERIAL
9190A-7 - 4274
SPARE DRAWING
9190A-7 - 4223
A-CP4220 DUCT 1 REMOTE I/O PANEL - TERMINAL LAYOUT & LEGENDS
9190A-7 - 4275
SPARE DRAWING
9190A-7 - 4224
SPARE DRAWING
9190A-7 - 4276
SPARE DRAWING
9190A-7 - 4225
A-CP4220 DUCT 1 REMOTE I/O PANEL - 120VAC POWER DISTRIBUTION
9190A-7 - 4277
SPARE DRAWING
9190A-7 - 4226
A-CP4220 DUCT 1 REMOTE I/O PANEL - 24VDC POWER DISTRIBUTION
9190A-7 - 4278
SPARE DRAWING
9190A-7 - 4227
SPARE DRAWING
9190A-7 - 4279
SPARE DRAWING
9190A-7 - 4228
SPARE DRAWING
9190A-7 - 4280
SPARE DRAWING
9190A-7 - 4229
SPARE DRAWING
9190A-7 - 4281
SPARE DRAWING
9190A-7 - 4230
A-CP4220 DUCT 1 REMOTE I/O PANEL - I/O WIRING DIAGRAM, RACK C SLOTS 0 & 1
9190A-7 - 4282
SPARE DRAWING
9190A-7 - 4231
9190A-7 - 4283
SPARE DRAWING
9190A-7 - 4232
9190A-7 - 4284
SPARE DRAWING
9190A-7 - 4233
9190A-7 - 4285
SPARE DRAWING
9190A-7 - 4234
SPARE DRAWING
9190A-7 - 4286
SPARE DRAWING
9190A-7 - 4235
SPARE DRAWING
9190A-7 - 4287
SPARE DRAWING
9190A-7 - 4236
SPARE DRAWING
9190A-7 - 4288
SPARE DRAWING
9190A-7 - 4237
SPARE DRAWING
9190A-7 - 4289
SPARE DRAWING
9190A-7 - 4238
SPARE DRAWING
9190A-7 - 4290
SPARE DRAWING
9190A-7 - 4239
SPARE DRAWING
9190A-7 - 4291
SPARE DRAWING
9190A-7 - 4240
A-CP4240 DUCT 2 REMOTE I/O PANEL - PANEL LAYOUT
9190A-7 - 4292
SPARE DRAWING
9190A-7 - 4241
A-CP4240 DUCT 2 REMOTE I/O PANEL - BACKPANEL LAYOUT
9190A-7 - 4293
SPARE DRAWING
9190A-7 - 4242
SPARE DRAWING
9190A-7 - 4294
SPARE DRAWING
9190A-7 - 4243
SPARE DRAWING
9190A-7 - 4295
SPARE DRAWING
9190A-7 - 4244
SPARE DRAWING
9190A-7 - 4296
SPARE DRAWING
9190A-7 - 4245
A-CP4240 DUCT 2 REMOTE I/O PANEL - 120VAC POWER DISTRIBUTION
9190A-7 - 4297
SPARE DRAWING
9190A-7 - 4246
A-CP4240 DUCT 2 REMOTE I/O PANEL - 24VDC POWER DISTRIBUTION
9190A-7 - 4298
SPARE DRAWING
9190A-7 - 4247
SPARE DRAWING
9190A-7 - 4299
SPARE DRAWING
9190A-7 - 4248
SPARE DRAWING
9190A-7 - 4249
SPARE DRAWING
9190A-7 - 4250
CONTROL SYSTEM
DRAWING INDEX
9190A-7 - 4251
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4005
DRAWING NUMBER
DESCRIPTION
9190A-7 - 4300
MECHANICAL/ELECTRICAL BUILDING - FIELD WIRING DIAGRAM
9190A-7 - 4301
BLOWERS - FIELD WIRING DIAGRAM
9190A-7 - 4302
BLOWER HEAT EXCHANGERS - FIELD WIRING DIAGRAM
9190A-7 - 4303
SILO EXTERIOR - FIELD WIRING DIAGRAM
9190A-7 - 4304
SILO SKIRT - FIELD WIRING DIAGRAM
9190A-7 - 4305
SCALE 1 - FIELD WIRING DIAGRAM
9190A-7 - 4306
9190A-7 - 4307
9190A-7 - 4308
9190A-7 - 4309
HOSE SWITCH - FIELD WIRING DIAGRAM
9190A-7 - 4310
DUCT 1 LANCE 1-4 VALVES - FIELD WIRING DIAGRAM
9190A-7 - 4311
9190A-7 - 4312
DUCT 1 PRESSURE TRANSMITTER PURGE SOLENOIDS - FIELD WIRING DIAGRAM
9190A-7 - 4313
DUCT 1 PRESSURE TRANSMITTERS - FIELD WIRING DIAGRAM
9190A-7 - 4314
9190A-7 - 4315
9190A-7 - 4316
DUCT 2 PRESSURE TRANSMITTER PURGE SOLENOIDS - FIELD WIRING DIAGRAM
9190A-7 - 4317
DUCT 2 PRESSURE TRANSMITTERS - FIELD WIRING DIAGRAM
CONTROL SYSTEM
DRAWING INDEX
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4006
WIRING LEGEND
- DENOTES PRE-WIRED
- DENOTES VENDOR PRE-WIRED
- DENOTES FIELD WIRED
A-MCP4100
TRUCK UNLOAD
MOTOR CONTROL PANEL
I/O CABLES
A-MCP4110
LINE 1
MOTOR CONTROL PANEL
20 AMP, 120VAC
I/O CABLES
A-CP4130
MAIN PLC PANEL
10 AMP,120VAC
CABLES
I
/O
I
/O
10 AMP,120VAC
20 AMP, 120VAC
CABLES
I/O CABLES
A-MCP4120
LINE 2
MOTOR CONTROL PANEL
A-JB4180
SILO DUST COLLECTOR
JUNCTION BOX
A-JB4190
SILO PANEL LEG
JUNCTION BOX
CABLES
CABLES
CABLES
CABLES
I
/O
I
/O
I
/O
I
/O
A-CP4170
SILO MARSHALLING
CABINET
A-CP4160
TRUCK UNLOAD PANEL
A-CP4220
DUCT 1
REMOTE I/O PANEL
A-JB4200
SILO SCALE 1
JUNCTION BOX
A-CP4240
DUCT 2
REMOTE I/O PANEL
A-JB4210
SILO SCALE 2
JUNCTION BOX
CONTROL SYSTEM
SYSTEM ARCHITECTURE
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4008
WIRING LEGEND
- DENOTES PRE-WIRED
A-CP4130
MAIN PLC PANEL
SPARE
1756-OF6CI
1756-OF6CI
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-EN2T
1756-PA75
POW ER SUPPLY
SPARE
1756-OA16
1756-OA16
1756-OA16
1756-OW 16
1756-I
A16
1756-I
A16
1756-I
A16
1756-I
A16
1756-I
A16I
MVI
56E-MNET
1756-EN2T
RACK B
192.168.1.101
1756-L75
1756-PA75
POW ER SUPPLY
RACK A
192.168.1.100
N-TRON
110FX2
110FX2
V1
N-TRON
102MC
V2
ETHERNET/IP - CAT5E
102MC
LNK/ACT
7
F
X
2
8
10/100
BaseTX
5
6
3
4
1
2
ETHERNET/IP - CAT5E
MODBUS TCP/IP - CAT5E
MODBUS TCP/IP - FIBER
LNK
ACT
LNK/ACT
F
X
1
RX
TO
CUSTOMER
DCS
100
BaseFX
TX
A-CP4220
DUCT 1 REMOTE I/O PANEL
N-TRON
102MC
RACK C
192.168.1.102
9
102MC
ALLEN-BRADLEY
8
1794-AENT
7
10/100
6
BaseTX
MODULE STATUS
ETHERNET/IP - FIBER
ETHERNET/IP - CAT5E
LNK
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
0
1
2
3
6
5
4
NETWORK STATUS
LINK STATUS
ACT
RX
100
BaseFX
TX
A-CP4240
DUCT 2 REMOTE I/O PANEL
N-TRON
102MC
RACK D
192.168.1.103
9
102MC
ALLEN-BRADLEY
8
1794-AENT
7
10/100
6
BaseTX
MODULE STATUS
ETHERNET/IP - FIBER
ETHERNET/IP - CAT5E
LNK
ACT
0
5
1
4
9
2
8
3
7
6
0
5
1
4
9
2
8
3
7
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
0
1
2
3
6
5
4
NETWORK STATUS
LINK STATUS
RX
100
BaseFX
TX
CONTROL SYSTEM
COMMUNICATION ARCHITECTURE
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4009
480VAC, 3 , 60Hz, 600A
FED FROM OMU
A-PDP4020
480VAC DISTRIBUTION PANEL
SHT.4011
600A
LGH3600
3P
DISCONNECT
3P
80A
MCP
3P
7A
MCP
NEMA
SIZE 4
NEMA
SIZE 0
3P
100A
HFD
3P
DISCONNECT
3P
70A
MCP
7A
MCP
3P
3P
7A
MCP
PF753
VFD
PF753
VFD
PF753
VFD
3P
100A
HFD
3P
DISCONNECT
3P
70A
MCP
3P
3P
7A
MCP
100A
HFD
3P
15A
HFD
3P
30A
HFD
3P
20A
HFD
CONTI
NUED
100A
HFD
A-MCP4120
LI
NE 2 MOTOR CONTROL PANEL
3P
A-MCP4110
LI
NE 1 MOTOR CONTROL PANEL
A-MCP4100
T.U.MOTOR CONTROL PANEL
ON
3P
7A
MCP
3P
PF753
VFD
PF753
VFD
PF753
VFD
60HP
2HP
50HP
2HP
2HP
50HP
2HP
2HP
UNIT 2
TRUCK UNLOAD
BLOWER MOTOR
77.0 FLA
UNIT 2
T.U. BLOWER
HEAT EXCHANGER
MOTOR
3.4 FLA
UNIT 2 DSI
LINE 1
BLOWER MOTOR
65.0 FLA
UNIT 2 DSI
LINE 1
HEAT EXCHANGER
MOTOR
3.4 FLA
UNIT 2 DSI
SCALE 1 METER.
DROP THRU
AIRLOCK MOTOR
3.4 FLA
UNIT 2 DSI
LINE 2
BLOWER MOTOR
65.0 FLA
UNIT 2 DSI
LINE 2
HEAT EXCHANGER
MOTOR
3.4 FLA
UNIT 2 DSI
SCALE 2 METER.
DROP THRU
AIRLOCK MOTOR
3.4 FLA
UNIT 2
AIR
COMPRESSOR 1
UNIT 2 DSI
SILO JIB
CRANE
UNIT 2 DSI
SILO
HEATER
UNIT 2 DSI
ELECTRICAL
BUILDING HVAC
ONE-LINE LEGEND
1A
25HP HD
ABB VFD
MCC
COMPARTMENT
CIRCUIT BREAKER
(SIZE AS SHOWN)
VARIABLE
FREQUENCY
DRIVE
FUSE (SIZE
AS SHOWN)
FULL VOLTAGE
NON-REVERSING
STARTER (SIZE
AS SHOWN)
THERMAL MAGNETIC WITH
NON-INTERCHANGEABLE
TRIP UNITS
HFD
F-FRAME
(10-225 AMPERES)
HKD
K-FRAME
(10-400 AMPERES)
WELDING
RECEPTACLE
HMCP
CONTROL SYSTEM
ONE-LINE DIAGRAM
F-FRAME MOTOR
CIRCUIT PROTECTOR
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
03.Dec.14
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4010
A-PDP4020
CONTI
NUED FROM
SHT.4010
480VAC DISTRIBUTION PANEL
3P
60A
HFD
UNIT 2 DSI
WELDING
RECEPTACLE
3P
60A
HFD
UNIT 2 DSI
45KVA
LIGHTING
TRANSFORMER
3P
45A
HFD
UNIT 2 DSI
30KVA
CONTROL
TRANSFORMER
3P
25A
HFD
UNIT 2 DSI
15KVA
HEAT TRACE
TRANSFORMER
45A
HFD
3P
UNIT 2
TRUCK UNLOAD
DEHUMIDIFIER
ONE-LINE LEGEND
1A
25HP HD
ABB VFD
MCC
COMPARTMENT
CIRCUIT BREAKER
(SIZE AS SHOWN)
VARIABLE
FREQUENCY
DRIVE
FUSE (SIZE
AS SHOWN)
FULL VOLTAGE
NON-REVERSING
STARTER (SIZE
AS SHOWN)
THERMAL MAGNETIC WITH
NON-INTERCHANGEABLE
TRIP UNITS
HFD
F-FRAME
(10-225 AMPERES)
HKD
K-FRAME
(10-400 AMPERES)
WELDING
RECEPTACLE
HMCP
CONTROL SYSTEM
ONE-LINE DIAGRAM
F-FRAME MOTOR
CIRCUIT PROTECTOR
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
03.Dec.14
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4011
20"
5ƒ"
A-PDP4020
MAIN LUGS
600A
NEUTRAL
1
3
100A
80A
4
5
6
7
8
9
80A
80A
10
11
12
13
14
15
60A
60A
16
17
18
19
20
21
72"
2
45A
40A
23
24
25
27
26
20A
25A
29
32
20A
15A
35
34
36
37
39
28
30
31
33
22
38
15A
15A
41
40
42
BUS COVER
BUS COVER
EATON
P3D600LT42CH01
20.00"W x 72.00"H x 5.75"D
BUS COVER
A-PDP4020 480Y/277V DISTRIBUTION PANEL
PANEL LAYOUT
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
1/4"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4020
BARE
REF.
XXXX-XX
00
40
3-BK (Y)
0 SP
2-BK (O)
1-BK (BR)
02
480Y/277V DIST. PANEL - A-PDP4020
04
LOCATED IN THE ELECTRICAL ROOM
L1
BUS SIZE - 42 CIRCUIT
REF.
4300-00
1-BK (BR)
L3
G
LOAD
WIRE
AMPS
VOLTS - 480VAC
POLE
402106
POLE AMPS
WIRE
44
PHASE - 3 PHASE 3 WIRE
LOAD
DESCRIPTION
402146
1
L
02CBG4004
L2
MAIN LUGS - 600 AMP
DESCRIPTION
06
42
GND TO BUILDING
CKT-1
1-BK (BR)
L
CKT-2
2-BK (O)
402107
3-BK (Y)
402108
08
UNIT 2
AIR COMPRESSOR 1
1-BK (BR)
402109
2-BK (O)
402110
CKT-3
-
-
100
3
3
80
-
CKT-4
-
CKT-5
UNIT 2 TRUCK UNLOAD
MOTOR CONTROL PANEL
2-BK (O)
402148
3-BK (Y)
402149
1-BK (BR)
402150
2-BK (O)
402151
3-BK (Y)
402152
1-BK (BR)
48
L
CKT-6
CKT-7
402147
L
1
L
02CBG4002
2
3
L
CKT-8
L
CKT-10
UNIT 2 LINE 2
L
MOTOR CONTROL PANEL
0 SP
10
3-BK (Y)
402111
1-BK (BR)
402112
UNIT 2 LINE 1
L
MOTOR CONTROL PANEL
CKT-9
-
-
80
3
3
80
-
-
CKT-11
50
CKT-12
L
CKT-14
L
1
L
02CBG4010
4303-32
2
3
L
12
CKT-13
4031-00
402113
L
3-BK (Y)
1-BK (BR)
UNIT 2
WELDING RECEPTACLE
2
CKT-15
-
-
60
3
402114
14
60
-
CKT-16
-
UNIT 2 45KVA UTILITY
TRANSFORMER
CKT-17
L
CKT-19
402153
2-BK (O)
402154
3-BK (Y)
L
3
L
402115
02CBG4014
3
CKT-18
L
CKT-20
L
54
402155
1
1-BK (BR)
0 SP
2-BK (O)
402116
16
L
3-BK (Y)
402117
1-BK (BR)
402118
UNIT 2 TRUCK UNLOAD
DEHUMIDIFIER
-
-
45
3
3
40
-
CKT-22
-
CKT-23
UNIT 2 30KVA CONTROL
L
TRANSFORMER
CKT-24
L
CKT-25
CKT-26
L
402156
2-BK (O)
402157
3-BK (Y)
402158
1-BK (BR)
56
1
L
02CBG4007
2
CKT-21
3
L
REF.
4304-00
02CBG4006
0 SP
58
0 SP
2-BK (O)
402119
L
3-BK (Y)
UNIT 2 ELECTRICAL
BUILDING HVAC
CKT-27
-
-
20
3
25
-
UNIT 2 SILO
HEATER
CKT-28
-
CKT-29
CKT-31
2-BK (O)
402160
3-BK (Y)
402161
1-BK (BR)
L
60
1
L
402159
L
CKT-30
402121
02CBG4013
3
3
L
1-BK (BR)
2
402120
20
REF.
4061-00
REF.
4041-00
02CBG4012
0 SP
18
52
0 SP
2-BK (O)
REF.
4300-17
REF.
02CBG4011
0 SP
REF.
4302-21
REF.
4125-00
02CBG4003
0 SP
REF.
46
0 SP
L
REF.
4115-00
REF.
4105-00
02CBG4001
0 SP
L
CKT-32
REF.
4303-00
02CBG4005
0 SP
0 SP
2-BK (O)
402122
22
L
3-BK (Y)
UNIT 2 15KVA HEAT
TRACE TRANSFORMER
2
CKT-33
-
-
20
3
402123
3
15
-
UNIT 2 SILO
JIB CRANE
CKT-34
-
CKT-35
L
CKT-37
2-BK (O)
402163
3-BK (Y)
62
3
L
402162
L
CKT-36
L
CKT-38
L
1
24
L
SPARE
BREAKER
2
CKT-39
-
-
15
3
3
15
-
SPARE
BREAKER
CKT-40
-
64
L
3
26
L
CKT-41
66
L
CKT-42
28
68
30
70
32
72
NOTE:
ALL CABLES GROUND TO GROUND
BAR LOCATED IN DISTRIBUTION PANEL
WIRING LEGEND
A-PDP4020 480Y/277V DISTRIBUTION PANEL
- DENOTES PRE-WIRED
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4021
22‡"
16…"
30"
A-XFMR4030
EATON
V48M28F45EE
22.90"W x 29.99"H x 16.42"D
A-XFMR4030 45KVA UTILITY TRANSFORMER
LAYOUT
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
1/2"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4030
WIRING LEGEND
- DENOTES PRE-WIRED
X0
BARE
0 SP
02
N403100
02CBE4050
A
GND
X1
40
403102
1-BK (BR)
42
1-BK (BR)
04
A
H1
12 3 4 5 6 7 8
402152
REF.
4036-00
0 SP
B
GND
02CBG4011
44
B
REF.
4021-52
12 3 4 5 6 7 8
00
X2
403105
2-BK (O)
08
46
A
2-BK (O)
B
06
H2
12 3 4 5 6 7 8
402153
X3
403108
3-BK (Y)
402154
48
H3
3-BK (Y)
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
A-XFMR4030 45KVA UTILITY TRANSFORMER
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4031
20"
5ƒ"
A-PDP4035
MAIN LUGS
225A
1
2
20A
20A
42"
3
4
5
20A
20A
6
7
20A
20A
8
9
20A
20A
10
11
20A
20A
12
13
20A
20A
14
15
20A
15A
16
17
15A
15A
18
19
20A
20A
20
21
20A
20A
22
23
20A
20A
24
25
20A
20A
26
27
20A
20A
28
29
-
-
30
31
-
-
32
33
-
-
34
35
-
-
36
37
-
-
38
39
-
-
40
41
-
-
42
BLANK COVER
2 INCHES
EATON
P1A225LT42CH01
20.00"W x 42.00"H x 5.75"D
A-PDP4035 208Y/120V UTILITY DIST. PANEL
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
3/8"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4035
REF.
4031-00
00
N403100
40
02CBE4050
3-BK (Y)
403108
2-BK (O)
403105
0 SP
1-BK (BR) 403102
02
UTILITY DIST. PANEL - A-PDP4035
04
LOCATED IN THE ELECTRICAL ROOM
L1
BUS SIZE - 42 CIRCUIT
REF.
4081-00
L2
L3
N
G
MAIN - 225 AMP
DESCRIPTION
06
42
GND TO BUILDING
LOAD
VOLTS - 208/120VAC
WIRE
AMPS
POLE
H403606
POLE AMPS
WIRE
44
PHASE - 3 PHASE 4 WIRE
LOAD
DESCRIPTION
H403646
1
L
02CBE4095
CKT-1
UNIT 2 DSI SILO
LIGHTING CONTACTOR
0 SP
H403607
L
CKT-2
-
-
20
2
2
20
-
L
02CBE4096
UNIT 2 ACI SILO
LIGHTING CONTACTOR
-
2
CKT-3
CKT-4
08
L
02CBD4097
N403608
1-BK
H403609
10
2-R
N403609
1-BK
H403610
12
2-R
N403610
H403611
2-R
N403611
1-BK
H403612
REF. 9190B-7
4302-34
2-R
N403612
REF.
4300-10
1-BK
H403613
2-R
N403613
1-BK
H403614
2-R
N403614
REMOTE I/O PANEL
1-BK
H403615
2-R
N403615
H403616
2-R
N403616
CKT-7
-
-
20
1
1
20
-
CKT-8
-
2
-
-
20
1
1
20
-
UNIT 2 ELECTRICAL ROOM
CKT-10
LIGHTING
-
2-R
N403617
3
-
-
20
1
1
20
-
-
UNIT 2 ELECTRICAL ROOM
CKT-12
RECEPTACLES
-
UNIT 2 ACI SILO
RECEPTACLES
1
-
-
20
1
1
20
-
CKT-14
UNIT 2 DSI SILO
RECEPTACLES
2
CKT-15
-
-
20
1
1
15
-
UNIT 2 DSI SILO
EXHAUST FAN
CKT-16
-
UNIT 2 ACI SILO
EXHAUST FAN
3
CKT-17
-
-
15
1
1
15
-
CKT-18
-
1-BK
H403618
2-R
N403618
2-R
N403619
2-R
0 SP
1
CKT-19
-
-
20
1
1
20
-
CKT-20
-
UNIT 2 AIR
COMPRESSOR 1 DRYER
2
CKT-21
-
-
20
1
1
20
-
CKT-22
-
1-BK
N403651
2-R
H403652
1-BK
N403652
2-R
UNIT 2 ACI LINE 1
MOTOR CONTROL PANEL
3
CKT-23
-
-
20
1
1
20
-
CKT-24
-
XXXX-XX
-
-
20
1
1
20
-
CKT-26
-
UNIT 2 BUILDING
SMOKE DETECTORS
H403653
1-BK
N403653
2-R
REF.
4304-34
02CBD4108
0 SP
H403654
1-BK
N403654
2-R
REF.
4106-00
02CBD4110
54
0 SP
H403655
1-BK
N403655
2-R
REF.
4128-00
02CBD4114
0 SP
H403656
1-BK
N403656
2-R
L
REF. 9190B-7
4300-10
02CBD4118
56
0 SP
H403657
1-BK
N403657
2-R
REF. 9190B-7
4177-61
02CBD4121
0 SP
H403658
1-BK
N403658
2-R
REF.
XXXX-XX
L
N
UNIT 2 BUILDING
EXTERIOR RECEPTACLES
52
0 SP
L
UNIT 2 ACI LINE 2
L
MOTOR CONTROL PANEL
1
CKT-25
REF.
02CBD4106
N
UNIT 2 BUILDING
EXTERIOR LIGHTING
REF.
XXXX-XX
0 SP
L
UNIT 2 DSI LINE 2
L
MOTOR CONTROL PANEL
50
0 SP
02CBD4104
UNIT 2 TRUCK UNLOAD
L
MOTOR CONTROL PANEL
UNIT 2 AIR
COMPRESSOR 2 DRYER
REF.
XXXX-XX
02CBD4102
N
L
0 SP
N403650
N
L
H403619
1-BK
L
N
1-BK
2-R
H403650
N
UNIT 2 DSI LINE 1
MOTOR CONTROL PANEL
REF. 9190B-7
4245-00
02CBD4100
N403649
H403651
N
0 SP
0 SP
N
L
02CBD4119
1-BK
N
L
H403617
H403649
L
N
1-BK
2-R
N
L
1-BK
1-BK
N403648
02CBD4098
UNIT 2 ACI DUCT 2
L
REMOTE I/O PANEL
N
02CBD4117
H403648
L
N
02CBD4112
REF.
XXXX-XX
CKT-6
-
N
L
02CBD4109
REF.
XXXX-XX
-
N
0 SP
18
20
N
L
02CBD4107
0 SP
REF. 9190B-7
4177-21
1
N
0 SP
16
1
N
UNIT 2 MECHANICAL ROOM
L
CKT-13
RECEPTACLES 2
02CBD4105
0 SP
REF.
4118-00
20
N
0 SP
14
-
1
L
CKT-11
RECEPTACLES 1
02CBD4103
0 SP
REF.
XXXX-XX
-
UNIT 2 ACI DUCT 1
N
1-BK
XXXX-XX
CKT-5
L
CKT-9
LIGHTING
02CBD4101
0 SP
REF.
3
N
0 SP
REF.
XXXX-XX
REMOTE I/O PANEL
UNIT 2 DSI DUCT 2
L
REMOTE I/O PANEL
02CBD4099
0 SP
REF.
XXXX-XX
UNIT 2 DSI DUCT 1
N
0 SP
REF.
4245-00
48
N403647
N
H403608
2-R
REF. 9190B-7
4225-00
L
N
1-BK
46
H403647
N403607
REF.
4225-00
REF. 9190B-7
4081-00
0 SP
58
0 SP
2
CKT-27
-
-
20
1
1
20
-
-
CKT-28
SPARE BREAKER
1
-
-
-
CKT-30
-
1
-
-
-
CKT-32
-
1
-
-
-
CKT-34
-
1
-
-
-
CKT-36
-
1
-
-
-
CKT-38
-
1
-
-
-
CKT-40
-
1
-
-
-
CKT-42
-
N
3
20
-
CKT-29
-
-
-
1
60
1
-
CKT-31
-
-
-
1
-
CKT-33
-
-
-
1
2
22
62
3
-
CKT-35
-
-
-
1
-
CKT-37
-
-
-
1
1
24
64
2
-
CKT-39
-
-
-
1
-
CKT-41
-
-
-
1
3
26
66
28
68
30
70
32
72
NOTE:
ALL CABLES GROUND TO GROUND
BAR LOCATED IN DISTRIBUTION PANEL
WIRING LEGEND
A-PDP4035 208Y/120V UTILITY DIST. PANEL
- DENOTES PRE-WIRED
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4036
22‡"
16…"
30"
A-XFMR4040
EATON
V48M28F30EE
22.90"W x 29.99"H x 16.42"D
A-XFMR4040 30KVA CONTROL TRANSFORMER
LAYOUT
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
1/2"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4040
WIRING LEGEND
- DENOTES PRE-WIRED
X0
BARE
0 SP
02
N404100
02CBD4051
A
GND
X1
40
404102
1-BK (BR)
42
1-BK (BR)
04
A
H1
12 3 4 5 6 7 8
402155
REF.
4055-00
0 SP
B
GND
02CBG4012
44
B
REF.
4021-55
12 3 4 5 6 7 8
00
X2
404105
2-BK (O)
08
46
A
2-BK (O)
B
06
H2
12 3 4 5 6 7 8
402156
X3
404108
3-BK (Y)
402157
48
H3
3-BK (Y)
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
A-XFMR4040 30KVA CONTROL TRANSFORMER
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4041
8"
2
6‡ "
3• "
3
0"
1
4"
0"
A-PDP4050
CB
TB1
CB
4
CB
7
8"
6
TB1 (3) 1492-J6
9
8
5
10
6ƒ"
ENCLOSURE:
NEMA 12
HOFFMAN A808CH
8.00"H x 8.00"W x 4.00"D
BACKPANEL:
HOFFMAN A8P8
6.88"H x 6.88"W
A-PDP4050 CONTROL DISTRIBUTION PANEL
PANEL & BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1"=1"
c
CATALOG NO.
65585
2007
DRAWING NO.
9190A-7-4050
NOL-TEC SYSTEMS INC. JOBSCOPE CATALOG # 65585
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 12, 8" X 8" X 4"
HOFFMAN
MANUFACTURER
A-808CH
PART No.
2
1
BACK PANEL, 6.75" X 6.88"
HOFFMAN
A8P8
3
1
LEGEND - AS REQUIRED BY JOB - PLASTIC
PER PRINT/LIST
LEGEND
4
3
CIRCUIT BREAKER, 1 POLE, 30 AMP, DIN MOUNT, C-TRIP
ALLEN-BRADLEY
1489-M1C300
5
1
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
6
3
TERMINAL BLOCK, 600V, 50A, GREY
ALLEN-BRADLEY
1492-J6
7
1
JUMPER, SCREW CENTER JUMPER LINK, 4-POLE, FOR 1492-J6'S
ALLEN-BRADLEY
1492-CJJ8-4
8
2
END ANCHOR, DIN RAIL, J-SERIES, STANDARD DUTY
ALLEN-BRADLEY
1492-EAJ35
9
1
END BARRIER (USED ON 1492-J3, J4, J6 & J10) GREY
ALLEN-BRADLEY
1492-EBJ3
10
7"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65585
2007
DRAWING NO.
9190A-7-4052
STICKERS TO BE MOUNTED TO THE INTERIOR OF THE DOOR
LEGENDS FOR DOOR LAYOUT
TB1
404102
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-PDP4050
.
ƒ" x 4•"
•"
WHITE
BLACK
405500
CB & FUSE CHART
1
404105
405504
2
404108
3
TB1-1
30
AMP
4
TB1-2
30
AMP
TB1-3
30
AMP
N404100
5
1
A-PDP4050
6
JOB #9190A
120/1/60
CONTROL VOLTAGE = 120 VAC
TOTAL FULL LOAD AMPS = 30
HOLES IN ENCLOSURE
MUST BE FILLED WITH
NEMA TYPE 12 DEVICES
WIRING TERMINALS USE
COPPER WIRE WITH
60 DEG C INSULATION
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
ENCLOSED INDUSTRIAL CONTROL PANEL
No. AA-______
TB1
TERMINAL LAYOUT & LEGENDS
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65585
2007
DRAWING NO.
9190A-7-4053
WIRING LEGEND
- DENOTES PRE-WIRED
CB-405500
00
REF.
4041-00
404102
02CBD4051
1-BK (BR)
0 SP
405500
30A
TB1-1
N404100
02CBD4150
1-BK
REF.
4135-00
0 SP
120VAC POWER TO
A-CP4130 MAIN
PLC PANEL
40
N404100
02
TB1-4
42
2-R
CB-405504
404105
04
2-BK (O)
405504
30A
TB1-2
02CBD4160
1-BK
0 SP
REF.
9190B-7
4135-00
120VAC POWER TO
B-CP4130 MAIN
PLC PANEL
44
N404100
06
TB1-5
2-R
46
CB-405508
404108
08
3-BK (Y)
30A
TB1-3
10
48
50
TB1-6
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4055
22‡"
16…"
30"
A-XFMR4050
EATON
V48M28F15EE
22.90"W x 29.99"H x 16.42"D
A-XFMR4060 15KVA HEAT TRACE TRANSFORMER
LAYOUT
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
1/2"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4060
WIRING LEGEND
- DENOTES PRE-WIRED
X0
BARE
0 SP
02
N406100
02CBG4030
A
GND
X1
40
406102
1-BK (BR)
42
1-BK (BR)
04
A
H1
12 3 4 5 6 7 8
402121
REF.
4075-02
0 SP
B
GND
02CBG4013
44
B
REF.
4021-21
12 3 4 5 6 7 8
00
X2
406105
2-BK (O)
08
46
A
2-BK (O)
B
06
H2
12 3 4 5 6 7 8
402122
X3
406108
3-BK (Y)
402123
48
H3
3-BK (Y)
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
A-XFMR4060 15KVA HEAT TRACE TRANSFORMER
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4061
24"
1
8"
C DOOR
L
A-PDP4070
4
OUTSIDE TEMP.
BELOW 35°
3
4
3
4
3"
R
HEAT
4
1• "
C DOOR
L
1• "
R
WARNING!
POWER FED FROM
MULTPLE SOURCES
HEAT
TRACE 2 ON
3
4
3
4
R
3"
30"
TRACE 1 ON
HEAT
TRACE 3 ON
R
ENCLOSURE:
NEMA 12
HOFFMAN A-302408LP
30.00"H x 24.00"W x 8.00"D
A-PDP4070 HEAT TRACE DISTRIBUTION PANEL
BACKPANEL:
HOFFMAN A-30P24
27.00"H x 21.00"W
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65375
2007
DRAWING NO.
9190A-7-4070
21"
15• "
8‡ "
5† "
0"
2
0"
2" x 4" WIREWAY
TB1
8
CB
5
11
9
CB
12
13
14
CB
2" x 4" W I
REW AY
(30) 1492-J4
17
CB
3" x 4" W I
REW AY
15
TB1 (7) 1492-J6 &
10
2" x 4" W I
REW AY
CB
19
6
7
18
16
20
2" x 4" WIREWAY
27"
ENCLOSURE:
NEMA 12
HOFFMAN A-302408LP
30.00"H x 24.00"W x 8.00"D
BACKPANEL:
HOFFMAN A-30P24
27.00"H x 21.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65375
2007
DRAWING NO.
9190A-7-4071
NOL-TEC SYSTEMS INC. JOBSCOPE CATALOG #65375
ITEM
QTY.
DESCRIPTION
1
1
HOFFMAN
A-302408LP
2
1
BACK PANEL, 27.00" X 21.00"
HOFFMAN
A-30P24
3
4
PILOT LIGHT, RED, 12-130V, AC/DC, LED, NEMA 4X
ALLEN-BRADLEY
800H-QRH2R
4
6
LEGEND - AS REQUIRED BY JOB - PLASTIC PER PRINT/LIST
-
LEGEND
5
3
SWITCH, CURRENT STATUS, ADJ SET PT, CURRENT RANGE 1-135A, NO CONT, SOLID ST.
HAWKEYE
H-709
6
4
RELAY SOCKET, 8 PIN
ALLEN-BRADLEY
700-HN125
7
4
RELAY, DPDT, 10A, 120VAC, TUBE BASE
ALLEN-BRADLEY
700-HA32A1
8
1
CIRCUIT BREAKER, 3 POLE, 20 AMP, 480Y/277 VAC
ALLEN-BRADLEY
1489-M3C200
9
3
CIRCUIT BREAKER, 3 POLE, 10 AMP, DIN, C-TRIP
ALLEN-BRADLEY
1489-M3C100
10
1
ALLEN-BRADLEY
1489-M1C100
11
7
ALLEN-BRADLEY
1492-J6
12
30
TERMINAL BLOCK, 22 AWG, 600V, 35 AMP
ALLEN-BRADLEY
1492-J4
13
1
JUMPER BAR, CENTER, 10 POLE, FOR 1492-J4
ALLEN-BRADLEY
1492-CJJ6-10
14
1
ALLEN-BRADLEY
1492-CJJ6-4
15
7
END BARRIER (USED ON 1492-J3, J4, J6, & J10) GREY
ALLEN-BRADLEY
1492-EBJ3
16
4
ALLEN-BRADLEY
1492-EAJ35
17
1
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
18
32"
WIRE DUCT, 3" WD, 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 80X100 3240360
19
105" WIRE DUCT, 2" WD, 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 60X100 3240355
20
38"
ALLEN-BRADLEY
199-DR1
DIN RAIL
MANUFACTURER
PART No.
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65375
2007
DRAWING NO.
9190A-7-4072
TB1
406102
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-PDP4070
.
ƒ" x 4•"
•"
WHITE
BLACK
2
1
HEAT
TRACE 1 ON
2‚" x 2‚"
‰"
WHITE
BLACK
3
1
HEAT
TRACE 2 ON
2‚" x 2‚"
‰"
WHITE
BLACK
4
1
HEAT
TRACE 3 ON
2‚" x 2‚"
‰"
WHITE
BLACK
5
1
AMBIENT TEMP.
BELOW 35°
2‚" x 2‚"
‰"
WHITE
BLACK
6
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
407502A
406105
CB & FUSE CHART
407503A
1
406108
407504A
TB1-1
20
AMP
407502
TB1-3
10
AMP
407503
TB1-6
10
AMP
407504
TB1-9
10
AMP
TB1-12
10
AMP
N406100
2
407502A
407503A
3
407504A
407502
4
5
407508
1
407509
6
A-PDP4070
407510
407508
JOB #9190A
7
480/3/60
8
407514
2
3
4
407515
5
HEAT
HEAT
HEAT
AMBIENT TEMP.
TRACE 1 ON
TRACE 2 ON
TRACE 3 ON
BELOW 35°
9
407516
407514
10
11
413520
407602
12
N404100
13
HOLES IN ENCLOSURE
14
MUST BE FILLED WITH
15
16
17
407602
18
6
WARNING!
POWER FED FROM
MULTPLE SOURCES
19
20
21
22
COPPER WIRE WITH
407501
23
407606
60 DEG C INSULATION
24
407507
25
407614
26
407513
27
407622
28
407632
29
TERMINAL BLOCK
30
TIGHTENING TORQUE
407634
414200
31
1492-J4 - 9.0 LB-IN
32
414226
33
1492-J6 - 14.2 LB-IN
34
1492-H... - 7.1 LB-IN
414228
414230
35
414232
36
37
38
U
L
39
R
Underwriters
Laboratories Inc.
R
40
LISTED
41
42
No. AA-______
TB1
2‚"
0„ "
1Œ "
2‚ "
0‰"
1‰"
1„"
30.5mm
1
26AUG15
0
01JUN15
PANEL AS BUILT
LEGEND DETAIL
REV
DATE
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65375
2007
DRAWING NO.
9190A-7-4073
WIRING LEGEND
- DENOTES PRE-WIRED
407501
02
REF.
4061-00
CB-407502A
406102
407502A
REF.
4076-04
407502
407502
02CBG4031
SEE NOTE
0 SP
TB1-4
407503A
406108
04
CB-407502
02CBG4030
406105
UNIT 2 HEAT TRACE
CIRCUIT 1
CURRENT MONITOR
407602
00
REF.
XXXX-XX
0 SP
UNIT 2
HEAT TRACE
CIRCUIT 1
407503
407504A
407504
20A
TB1-1
10A
TB1-3
TB1-2
TB1-5
N406100
N406100
UNIT 2 HEAT TRACE
CIRCUIT 2
CURRENT MONITOR
407602
06
REF.
407507
4076-12
CB-407508
407508
407508
08
02CBG4032
SEE NOTE
TB1-7
REF.
XXXX-XX
0 SP
UNIT 2
HEAT TRACE
CIRCUIT 2
407509
407510
10
10A
TB1-6
N406100
TB1-8
UNIT 2 HEAT TRACE
CIRCUIT 3
CURRENT MONITOR
407602
12
407513
REF.
4076-20
CB-407514
407514
407514
14
02CBG4033
SEE NOTE
TB1-10
0 SP
REF.
XXXX-XX
UNIT 2
HEAT TRACE
CIRCUIT 3
407515
407516
16
10A
TB1-9
N406100
TB1-11
18
20
22
24
26
28
30
32
34
NOTE:
WIRING DIAGRAM
WRAP WIRE TWICE THROUGH
CURRENT MONITOR.
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4075
407602
N404100
WIRING LEGEND
- DENOTES PRE-WIRED
GND
REF.
4135-21
00
REF.
4142-25
40
02CBD4116
3-BL
0 SP
X SP
CB-407602
CR407604
407602
02
413520
10A
TB1-11
N404100
1-BK
2-R
407501
407501
N404100
TB1-17
REF.
4075-00
TB1-22
TB1-12
407606
N404100
3
TB1-17
UNIT 2 HEAT TRACE
CIRCUIT 1
CONTROL RELAY
R
TB1-23
TB1-13
414226
4-O
TB1-32
CR407612
414200
44
414228
8
414228
6
TB1-30
4076-06, 4076-42
UNIT 2 HEAT TRACE
CIRCUIT 1
ON PILOT LIGHT
414226
6
TB1-30
5-Y
TB1-33
LT407606
407606
1
N404100
7
414200
8
1-BK
TB1-12
2
CR407604
407602
06
414200
42
CR407604
407602
04
02CBD4222
CR407620
414200
46
414230
8
414230
6
TB1-31
6-BR
TB1-34
CR407632
414200
08
48
414232
8
10
414232
6
TB1-31
TB1-35
7-R/BK
UNIT 2 HEAT TRACE
CIRCUIT 1
ON SIGNAL
UNIT 2 HEAT TRACE
CIRCUIT 2
ON SIGNAL
UNIT 2 HEAT TRACE
CIRCUIT 3
ON SIGNAL
AMBIENT TEMPERATURE
BELOW 35°
SIGNAL
50
CR407612
407602
12
TB1-18
407507
REF.
407507
TB1-13
407614
N404100
3
TB1-18
CONTROL RELAY
4076-14, 4076-44
52
LT407614
407614
1
7
TB1-24
CR407612
407602
14
UNIT 2 HEAT TRACE
CIRCUIT 2
N404100
2
4075-06
R
TB1-25
TB1-14
UNIT 2 HEAT TRACE
CIRCUIT 2
ON PILOT LIGHT
54
16
56
18
58
CR407620
407602
20
TB1-19
REF.
4075-12
407513
407513
TB1-14
407622
N404100
3
TB1-19
UNIT 2 HEAT TRACE
CIRCUIT 3
CONTROL RELAY
4076-22, 4076-46
60
UNIT 2 HEAT TRACE
CIRCUIT 3
ON PILOT LIGHT
62
LT407622
407622
1
7
TB1-26
CR407620
407602
22
N404100
2
R
TB1-27
TB1-15
24
64
26
66
28
68
REF.
4300-33
30
70
0 SP
CR407632
407602
32
407632
407632
N404100
2
TB1-20
1-BK
2-R
TB1-28
407634
1
TB1-20
407602
TB1-15
AMBIENT TEMPERATURE
THERMOSTAT
CONTROL RELAY
4076-34, 4076-48
72
AMBIENT TEMPERATURE
BELOW 35°
PILOT LIGHT
74
LT407634
CR407632
407602
34
7
407634
3
N404100
R
TB1-28
TB1-16
N404100
407602
N404100
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4076
NOL-TEC SYSTEMS INC. JOBSCOPE CATALOG # 66668
No. Qty.
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
.
ƒ" x 3•"
‰"
WHITE
BLACK
2‚' x 2‚"
‰"
WHITE
BLACK
1
1
CP4080A
2
1
OFF
HAND
AUTO
1
CP4080A
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 8" x 6" x 4", 304SS
HOFFMAN
MANUFACTURER
A8064CHNFSS
PART No.
2
1
BACK PANEL, 6.75" x 4.88"
HOFFMAN
A8P6
3
1
SELECTOR SWITCH, 3 POS, 1 NO, 1 NC
ALLEN-BRADLEY
800H-JR2A
4
1
RELAY, 120VAC, SPDT, W/PILOT LIGHT
ALLEN-BRADLEY
700-HK36A1-4
5
1
SOCKET, RELAY, HN TYPE, DIN MNT, 5 BLD
ALLEN-BRADLEY
700-HN121
6
6"
DIN RAIL
ALLEN-BRADLEY
199-DR1
7
2
END ANCHOR, DIN RAIL HEAVY DUTY
ALLEN-BRADLEY
1492-EAJH35
8
1
LEGEND PLATE, WHITE, HAND-OFF-AUTO
ALLEN-BRADLEY
800H-W551
9
1
END BARRIER (USED ON 1492-J3, J4, J6 & J10)
ALLEN-BRADLEY
1492-EBJ3
10
5
TERMINAL BLOCK, 22-10 AWG, 600V, 35 AMP
ALLEN-BRADLEY
1492-J4
2
OFF
HAND
AUTO
NO CONDUIT ENTRY
IN THIS AREA
4"
6"
4 7 8"
0"
2716"
318"
0"
CP4080A
4 18"
11
10
4
CONDUI
T ENTRY
I
N THI
S AREA
TB1 (5) 1492-J4
7
NO
8"
AUTO
NO
CONDUI
T ENTRY
I
N THI
S AREA
HAND
5
9
OFF
6
3
2
1
634 "
TB1
01606
01606
TB1-1
N00401
N00401
TB1-2
04802
RECOMMENDED AREA
FOR CONDUIT ENTRY
2‚"
04802
TB1-3
04806
04806
TB1-4
04808
0‰"
04808
TB1-5
0„ "
1Œ "
2‚ "
CR04806
1‰"
01606
ENCLOSURE:
NEMA 4X
HOFFMAN A8064SHNFSS, 304SS
8.00"H x 6.00"W x 4.00"D
SUBPANEL:
HOFFMAN A8P6
6.75"H x 4.88"W
04806
11
A1
04808
N00401
14
A2
ESTIMATED WEIGHT: 50 LBS.
A-CP4080 LIGHTING CONTROL PANEL
PANEL LAYOUT
1„"
OWENSBORO, KY
0
10AUG15
REV
DATE
REVISION NOTE
JPN
ADH
DRAWN BY
J. NELSON
DATE
10.Aug.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
1"=1"
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4080
120VAC POWER FED
FROM CIRCUIT BREAKER CCT #1
REF. 02CBE4095 LINE 06
01606
00
N00401
GND
PC120
HAND
TB1-1 01606
02
OFF
AUTO
PHOTO-EYE
04802 TB1-3
oox
BLK
RED
04
N00401
WHT
SILO EXTERIOR
LIGHTING
PHOTOCELL
SILO EXTERIOR
LIGHTING CONTROL
RELAY 048-08
04806
CR04806
04806 TB1-4
06
TB1-1 01606
08
CR04806-1
11
TB1-2 N00401
A1
xoo
04808 TB1-5
CR
A2
N00401
14
048-04
SILO LOWER
LEVEL EXTERIOR
DOOR #1 LIGHT (150W)
LIGHT CONTROL ENCLOSURE
N00401
10
N00401
SILO UPPER
LEVEL EXTERIOR
N00401
SILO
STAIR TOWER
LIGHT #1 (150W)
N00401
SILO
STAIR TOWER
LIGHT #2 (150W)
12
14
16
N00401
18
N00401
20
SILO LOWER
LEVEL EXTERIOR
SILO
STAIR TOWER
LIGHT #3 (150W)
SILO
TOP
LIGHT (250W)
22
24
26
28
30
32
34
A-CP4080 LIGHTING CONTROL PANEL
WIRING DIAGRAM
OWENSBORO, KY
0
10JUL15
REV
DATE
REVISION NOTE
JPN
ADH
DRAWN BY
J. NELSON
DATE
10.Aug.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4081
25…"
10"
1
A-MCP4100
30"
3
3
WARNING!
POWER FED FROM
MULTPLE SOURCES
ENCLOSURE:
NEMA 12
HOFFMAN A-30SA2610LPPL
30.00"H x 25.38"W x 10.00"D
A-MCP4100 T.U. MOTOR CONTROL PANEL
BACKPANEL:
HOFFMAN A-30P24
27.00"H x 21.00"W
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65376
2007
DRAWING NO.
9190A-7-4100
21"
14"
10ƒ "
8‚ "
0"
2
0"
2" x 4" WIREWAY
5
6
7
8
SPACE RESERVED
FOR DISCONNECT
ON
OFF
OFF
2" x 4" W I
REW AY
ON
10"
9
10
4
13‚"
11
16ƒ"
16
2" x 4" WIREWAY
19‚"
1" x 4" W I
REW AY
TB1 (20) 1492-J4
CB
23„"
19
TB1
1" x 4" W I
REW AY
2" x 4" W I
REW AY
1" x 4" WIREWAY
18
2" x 4" WIREWAY
1" x 4" WIREWAY
27"
12
14
17
15
15
20
ENCLOSURE:
NEMA 12
30.00"H x 25.38"W x 10.00"D
BACKPANEL:
HOFFMAN A-30P24
27.00"H x 21.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65376
2007
DRAWING NO.
9190A-7-4101
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 12, 30" X 25.38" X 10" W/HANDLE
HOFFMAN
MANUFACTURER
A-305A2610LPPL
PART No.
2
1
BACK PANEL, 27.00" X 21.00"
HOFFMAN
A-30P24
3
2
PER PRINT/LIST
LEGEND
4
1
STARTER, NON-REV, CONTROL VOLTAGE, NEMA 0, 110V 50 HZ/120V 60HZ, 1.0-5.0 AMP
ALLEN-BRADLEY
309-AOD-EEC
5
1
CIRCUIT BREAKER, MOTOR PROTECTION, 80A, 480/415V
ALLEN-BRADLEY
140MG-G8P-C80
6
1
CIRCUIT BREAKER, MOTOR PROTECTION, 7A 480/415V
ALLEN-BRADLEY
140MG-G8P-B70
7
1
MOTOR CIRCUIT PROTECTOR, AUXILIARY CONTACT 2 NO, 1 ALARM, 250V
ALLEN-BRADLEY
140G-G-EAZR1A
8
1
MOTOR CIRCUIT PROTECTOR, AUXILIARY CONTACT 1 NC, 1 A, 250V
ALLEN-BRADLEY
140G-G-EA1A
9
1
CONTACTOR 3 POLE, 1 NO, 1 NC, AUX CONT, NON-REVERSE AC, 120/110 VAC COIL,130 AMP
ALLEN-BRADLEY
500FEOD930901
10
1
DISCONNECT SWITCH, NON-FUSED, 125 AMP, NON-METAL HANDLE, STD LUGS, 1 NO, 1 NC
ALLEN-BRADLEY
1494V-DN200-C-D-F-G
11
1
POWER DISTRIBUTION BLOCK 1 LINE, 4 LOAD
ALLEN-BRADLEY
1492-PDM3141
12
1
CIRCUIT BREAKER, 1 POLE, 15 AMP, DIN, C-TRIP 120VAC
ALLEN-BRADLEY
1489-M1C150
13
20
TERMINAL BLOCK, 22-10 AWG, 600V, 35A
ALLEN-BRADLEY
1492-J4
14
1
ALLEN-BRADLEY
1492-EBJ3
15
4
ALLEN-BRADLEY
1492-EAJ35
16
2
GROUND LUG, 1 HOLE, SINGLE BARREL POST
PANDUIT
ML4-CY
17
1
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
18
65"
PHOENIX CONTACT
CD-HF 60X100 3240355
19
35"
PHOENIX CONTACT
CD-HF 30X100 3240347
20
14"
DIN RAIL
ALLEN-BRADLEY
199-DR1
21
2
TERMINAL BLOCK, 300 VAC/VDC, 10 AMP, 2 LEVEL
ALLEN-BRADLEY
1492-JD3
22
1
END BARRIER (USED ON 1492-JD3)
ALLEN-BRADLEY
1492-EBJD3
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65376
2007
DRAWING NO.
9190A-7-4102
TB1
H403654
No. Qty.
1
1
1
2
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-MCP4100
.
ƒ" x 4•"
•"
WHITE
BLACK
*SEE LEGEND*
.
1‚" x 4"
WHITE
BLACK
‚"
410604
CB & FUSE CHART
1
N403654
2
GND
TB1-1
3
410513
15
AMP
4
414290
5
414240
6
1
N404100
A-MCP4100
7
414470
JOB #9190A
8
414272
9
480/3/60
10
410527
414472
11
2
WARNING!
POWER FED FROM
MULTPLE SOURCES
12
13
14
15
16
HOLES IN ENCLOSURE
17
MUST BE FILLED WITH
18
19
20
21
XXXXXX
22
XXXXXX
23
COPPER WIRE WITH
60 DEG C INSULATION
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65376
2007
DRAWING NO.
9190A-7-4103
WIRING LEGEND
- DENOTES PRE-WIRED
402146
00
REF.
4021-46
02CBG4001
1-BK (BR)
0 SP
402147
2-BK (O)
402148
02
3-BK (Y)
04
POWER
DIST.
BLOCK
140MG-G8P-C80
410502-L1
500F-EOD930-901
410506A
410506
06
02CBG4020
1-BK (BR)
REF.
4301-22
0 SP
410502-L2
410507A
UNIT 2 T.U.
BLOWER
MOTOR
60HP, 77.0 FLA
410507
2-BK (O)
410502-L3
410508A
08
414290
410508
GND
3-BK (Y)
BARE
414290
02CBD4237
140G-G-EA2R1A
TB1-5
12
10
414240
AX1
11
410511
N404100
X SP
UNIT 2 T.U. BLOWER
RUNNING
SIGNAL
1-BK
N404100
TB1-7
414470
12
TB1-8
22
REF.
4142-69
414240
TB1-6
14
4-O
2-R
414470
REF.
6-BR
4105-23
UNIT 2 T.U. BLOWER
MOTOR
STARTER
410513
AX2
21
24
UNIT 2 T.U. BLOWER
MOTOR
HEATER
REF.
4106-04
14
410602
96
16
AL1
95
98
18
140MG-G8P-B70
410502-L1
309-AOD-EEC
E1 PLUS
OL
410520A
410520
20
02CBG4021
1-BK (BR)
410502-L2
410521A
OL
410502-L3
410522A
OL
0 SP
410521
REF.
4302-14
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
MOTOR
2HP, 3.4 FLA
2-BK (O)
22
414272
140G-G-EA1A
3
2
TB1-9
410522
GND
3-BK (Y)
BARE
414272
REF.
4105-12
5-Y
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
RUNNING SIGNAL
414240
24
TB1-6
REMOVE
N404100
TB1-7
22
26
AX2
21
A2
24
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
MOTOR STARTER
410527
A1
4
5
410527
TB1-10
414472
414472
28
TB1-11
7-R/BK
30
32
410502-L3
410502-L2
410502-L1
34
480VAC POWER DISTRIBUTION
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4105
WIRING LEGEND
- DENOTES PRE-WIRED
REF.
4036-54
00
GND
40
02CBD4110
3-BL
02
TB1-3
0 SP
H403654
N403654
1-BK
2-R
42
CB-410604
410604
04
15A
TB1-1
REF.
4105-14
410513
TB1-4
410513
N403654
1-BK
2-R
TB1-2
02CBD4111
UNIT 2 T.U. BLOWER
MOTOR
HEATER
44
REF.
4301-25
0 SP
06
46
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4106
12"
37…"
6"
C DOOR
L
1
6"
6"
5
6"
A-MCP4110
6
6
6
LINE 1
BLOWER
6
LINE 1
BLOWER H.E.
8
7
4
8
9
5
1
SCALE 1
METERING RAL
7
5
4
3
8
9
5
1
7
5
4
3
9
5
1
2
2
0
0
0
3
3
5
3
2
3
12"
6
WARNING!
POWER FED FROM
C DOOR
L
16"
48"
MULTPLE SOURCES
4
ENCLOSURE:
NEMA 12
48.00"H x 37.38"W x 12.00"D
BACKPANEL:
HOFFMAN A-48P36
45.00"H x 33.00"W
A-MCP4110 LINE 1 MOTOR CONTROL PANEL
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/4"=1"
c
CATALOG NO.
65377
2007
DRAWING NO.
9190A-7-4110
24
33"
25‚ "
12… "
2• "
0"
2
0"
2" x 4" WIREWAY
11
ON
ON
OFF
OFF
SPACE
RESERVED
FOR
DISCONNECT
10
8
7
9„"
2" x 4" WIREWAY
10
10
9
9
2" x 4" W I
REW AY
13
19"
2" x 4" WIREWAY
ON
12
OFF
33•"
25
3" x 4" WIREWAY
1" x 4" WIREWAY
23
90
70
50
110
130
140
CB
30
1" x 4" W I
REW AY
TB1 (32) 1492-J4
1" x 4" W I
REW AY
TB2
1" x 4" W I
REW AY
TB1
CB
41"
2" x 4" W I
REW AY
37"
TB2 (24) 1492-J4-B
1" x 4" WIREWAY
45"
16
15
20
17
22
26
14
21
18
ENCLOSURE:
NEMA 12
48.00"H x 37.38"W x 10.00"D
19
BACKPANEL LAYOUT
BACKPANEL:
HOFFMAN A-48P36
45.00"H x 33.00"W
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65377
2007
DRAWING NO.
9190A-7-4111
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 12, 48" X 37.38" X 12" FLANGE MOUNTED DISCONNECT
HOFFMAN
MANUFACTURER
A-48SA3812LPPL
PART No.
2
1
BACK PANEL, 45.00" X 33.00"
HOFFMAN
A-48P36
3
3
DRIVE HIM, FULL NUMERIC LCD, POWER FLEX
ALLEN-BRADLEY
20-HIM-A6
4
1
ENCLOSURE, 4" COOLING FAN, W/COMPOSITE GRILLE, NEMA 12
HOFFMAN
TFP41UL12
5
1
ENCLOSURE, 4" EXHAUST GRILLE, NEMA 12
HOFFMAN
TEP41UL12
6
5
PER PRINT/LIST
LEGEND
7
1
DISCONNECT SWITCH, NON FUSED, 125 AMP
ALLEN-BRADLEY
1494V-DN200-C-D-F-G
8
1
DRIVE VFD, 480 VAC, 50 HP, HD, 65A 3PH POWERFLEX 753
ALLEN-BRADLEY
20F11NDO65AAONNNNN
9
2
DRIVE VFD, 380-480 VAC, 2HP, HD, POWERFLEX 753, NEMA 1
ALLEN-BRADLEY
20F11ND3P4AAONNNNN
10
3
I/O BOARD, DRIVE VFD, POWERFLEX 750 CLSS 120VAC, 2 ANA IN, 2 ANA OUT, 6 DI, 2 RO
ALLEN-BRADLEY
20-750-2262D-2R
11
2
ALLEN-BRADLEY
140MG-G8P-B70
12
1
ALLEN-BRADLEY
140MG-G8P-C70
13
1
POWER DISTRIBUTION BLOCK, 1 LINE, 4 LOAD
ALLEN-BRADLEY
1492-PDM3141
14
1
TEMPERTURE SWITCH, 15 AMP
HOFFMAN
ATEMNO
15
1
CIRCUIT BREAKER, 1 POLE, 15 AMP DIN, C-TRIP 120VAC
ALLEN-BRADLEY
1489-M1C150
16
1
CIRCUIT BREAKER, 1 POLE, 5 AMP DIN, C-TRIP
ALLEN-BRADLEY
1489-M1C050
17
30
ALLEN-BRADLEY
1492-J4
18
24
TERMINAL BLOCK, 22-10 AWG, 600V, BLUE
ALLEN-BRADLEY
1492-J4-B
19
8
ALLEN-BRADLEY
1492-EAJ35
20
1
ALLEN-BRADLEY
1492-EBJ3
21
1
END BARRIER (USED ON 1492-J3, J4, J6, & J10) BLUE
ALLEN-BRADLEY
1492-EBJ3-B
22
2
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
23
100" WIRE DUCT, 1" WD X 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 30X100 3240347
24
PHOENIX CONTACT
CD-HF
60X100 3240355
25
35"
WIRE DUCT, 3" WD X 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 80X100 3240360
26
41"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65377
2007
DRAWING NO.
9190A-7-4112
TB1
H403615
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
A-MCP4110
.
ƒ" x 4•"
•"
WHITE
BLACK
2
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
LINE 1
BLOWER
1" x 3"
‚"
WHITE
BLACK
LINE 1
BLOWER H.E.
1" x 3"
WHITE
BLACK
1
4
1
5
SCALE 1
METERING RAL
‚"
1" x 3"
‚"
WHITE
BLACK
N403615
TB2
411804
415044
411806
415042
SHLD
3
TB1-1
5
AMP
4
TB1-2
15
AMP
3
GND
414804
4
411531
414805
5
414240
5
SHLD
6
414242
6
415050
7
N404100
7
415048
8
414442
8
SHLD
9
1
424144
JOB #9190A
9
414808
10
A-MCP4110
CB & FUSE CHART
1
2
10
480/3/60
414809
11
414246
11
SHLD
12
12
415056
13
414444
14
2
414248
WARNING!
POWER FED FROM
MULTPLE SOURCES
13
415054
14
SHLD
15
15
414812
16
414250
16
414813
17
17
HOLES IN ENCLOSURE
SHLD
18
18
414446
19
19
MUST BE FILLED WITH
20
20
21
21
22
22
414252
3
4
LINE 1
BLOWER
5
LINE 1
BLOWER H.E.
SCALE 1
METERING RAL
23
23
24
24
25
26
27
COPPER WIRE WITH
28
60 DEG C INSULATION
29
30
31
32
33
TERMINAL BLOCK
34
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
TB2
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65377
2007
DRAWING NO.
9190A-7-4113
WIRING LEGEND
- DENOTES PRE-WIRED
402109
00
02CBG4002
1-BK (BR)
REF.
4021-09
0 SP
402110
2-BK (O)
402111
02
3-BK (Y)
04
POWER
DIST.
BLOCK
140MG-G8P-C70
OL
411502-L1
411506A
R
(L1)
06
OL
411502-L2
411507A
OL
411502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
411508A
20F11ND077AA0NNNNN
T
(L3)
08
411506
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4022
UNIT 2 DSI LINE 1
BLOWER
MOTOR
REF.
4301-00
0 SP
50HP, 65.0 FLA
411507
411508
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
REF.
12
415044
Ai0-
02CBA4504
4148-04
2-W
0 SP
TB2-1
415042
20-HIM-A6
31
UNIT 2 DSI LINE 1
BLOWER
SPEED REFERENCE
415042
42
TB2-2
SHLD
2-SH
FACTORY
HIM CABLE
J4
Ai0+
2-BK
14
DPI PORT 1
415044
SHLD
TB2-3
414805
414805
Ao0-
1-W
TB2-4
414804
16
UNIT 2 DSI LINE 1
BLOWER
OUTPUT FREQUENCY
414804
Ao0+
1-BK
REF.
4116-12
TB2-5
SHLD
1-SH
SHLD
TB2
TB2-6
18
R0NC
REF.
4142-41
414240
414240
R0C
02CBD4228
1-BK
X SP
TB1-6
414242
20
UNIT 2 DSI LINE 1
BLOWER
RUNNING SIGNAL
414242
R0NO
4-O
TB1-7
TB3
22
Di 0dc
N404100
N404100
Di C
2-R
TB1-8
414442
24
UNIT 2 DSI LINE 1
BLOWER
RUN COMMAND
414442
Di 0ac
6-BR
TB1-9
REF.
4116-22
20-750-2262D-2R
26
TB2
R0NC
414240
28
R0C
TB1-6
REF.
4116-20
414244
5-Y
R0NO
UNIT 2 DSI LINE 1
BLOWER
FAULTED SIGNAL
R1NC
UNIT 2 DSI LINE 1
BLOWER
MOTOR HEATER
414244
TB1-10
REF.
4116-18
30
411531
REF.
4118-06
32
411806
R1C
R1NO
411502-L3
411502-L2
411502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4115
411502-L3
411502-L2
411502-L1
WIRING LEGEND
- DENOTES PRE-WIRED
00
02
04
140MG-G8P-B70
OL
411502-L1
411606A
R
(L1)
06
OL
411502-L2
411607A
OL
411502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
411608A
20F11ND3P4AA0NNNNN
T
(L3)
08
411606
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4023
UNIT 2 DSI LINE 1
BLOWER HEAT EXCHANGER
MOTOR
REF.
4302-00
0 SP
2HP, 3.4 FLA
411607
411608
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
12
REF.
415048
4115-17
4-W
Ai0TB2-7
415050
20-HIM-A6
31
UNIT 2 DSI LINE 1
SPEED REFERENCE
415050
42
TB2-8
SHLD
4-SH
FACTORY
HIM CABLE
J4
Ai0+
4-BK
14
DPI PORT 1
415048
SHLD
TB2-9
414809
414809
Ao0-
3-W
TB2-10
414808
16
UNIT 2 DSI LINE 1
OUTPUT FREQUENCY
414808
Ao0+
3-BK
REF.
4117-12
TB2-11
SHLD
3-SH
SHLD
TB2
TB2-12
REF.
4115-30
18
R0NC
414240
R0C
TB1-11
REF.
4115-29
20
414246
UNIT 2 DSI LINE 1
RUNNING SIGNAL
414246
R0NO
7-R/BK
TB1-12
TB3
REF.
4115-25
22
Di 0dc
N404100
Di C
TB1-13
414444
24
UNIT 2 DSI LINE 1
RUN COMMAND
414444
Di 0ac
9-O/BK
TB1-14
REF.
4117-22
26
20-750-2262D-2R
TB2
R0NC
414240
28
R0C
TB1-11
REF.
4117-20
414248
UNIT 2 DSI LINE 1
FAULTED SIGNAL
414248
R0NO
8-BL/BK
TB1-15
REF.
4117-18
30
32
411502-L3
411502-L2
411502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4116
411502-L3
411502-L2
411502-L1
WIRING LEGEND
- DENOTES PRE-WIRED
00
02
04
140MG-G8P-B70
OL
411502-L1
411706A
R
(L1)
06
OL
411502-L2
411707A
OL
411502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
411708A
20F11ND3P4AA0NNNNN
T
(L3)
08
411706
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4024
UNIT 2 DSI SCALE 1
METER. DROP THRU AIRLOCK
MOTOR
REF.
4306-00
0 SP
2HP, 3.4 FLA
411707
411708
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
12
REF.
415056
4116-17
6-W
Ai0TB2-13
415054
20-HIM-A6
31
UNIT 2 DSI SCALE 1
SPEED REFERENCE
415054
42
TB2-14
SHLD
6-SH
FACTORY
HIM CABLE
J4
Ai0+
6-BK
14
DPI PORT 1
415056
SHLD
TB2-15
414813
414813
Ao0-
5-W
TB2-16
414812
16
UNIT 2 DSI SCALE 1
OUTPUT FREQUENCY
414812
Ao0+
5-BK
TB2-17
SHLD
5-SH
SHLD
TB2
TB2-18
REF.
4116-30
18
R0NC
414240
R0C
TB1-16
REF.
4116-29
20
414250
UNIT 2 DSI SCALE 1
RUNNING SIGNAL
414250
R0NO
10-Y/BK
TB1-17
TB3
REF.
4116-25
22
Di 0dc
N404100
Di C
TB1-18
414446
24
UNIT 2 DSI SCALE 1
RUN COMMAND
414446
Di 0ac
12-BK/R
TB1-19
20-750-2262D-2R
26
TB2
R0NC
414240
28
R0C
TB1-16
414252
UNIT 2 DSI SCALE 1
FAULTED SIGNAL
414252
R0NO
11-BR/BK
TB1-20
30
32
411502-L3
411502-L2
411502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4117
WIRING LEGEND
- DENOTES PRE-WIRED
REF.
4036-15
00
GND
40
02CBD4112
3-BL
02
CB-411804
411804
04
H403615
N403615
1-BK
2-R
TEMPERATURE
SWITCH
TB1-4
0 SP
42
411804A
5A
TB1-1
N403615
FAN
TB1-3
ENCLOSURE
COOLING
FAN
44
UNIT 2 DSI LINE 1
BLOWER
MOTOR HEATER
46
CB-411806
411806
06
15A
TB1-2
REF.
4115-31
411531
TB1-5
411531
N403615
1-BK
2-R
02CBD4113
REF.
4301-02
0 SP
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4118
12"
37…"
6"
C DOOR
L
1
6"
6"
5
6"
A-MCP4120
6
6
6
LINE 2
BLOWER
6
LINE 2
BLOWER H.E.
8
7
4
8
9
5
1
SCALE 2
METERING RAL
7
5
4
3
8
9
5
1
7
5
4
3
9
5
1
2
2
0
0
0
3
3
5
3
2
3
12"
6
WARNING!
POWER FED FROM
C DOOR
L
16"
48"
MULTPLE SOURCES
4
ENCLOSURE:
NEMA 12
48.00"H x 37.38"W x 12.00"D
BACKPANEL:
HOFFMAN A-48P36
45.00"H x 33.00"W
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/4"=1"
c
CATALOG NO.
65378
2007
DRAWING NO.
9190A-7-4120
24
33"
25‚ "
12… "
2• "
0"
2
0"
2" x 4" WIREWAY
11
ON
ON
OFF
OFF
SPACE
RESERVED
FOR
DISCONNECT
10
8
7
9„"
2" x 4" WIREWAY
10
10
9
9
2" x 4" W I
REW AY
13
19"
2" x 4" WIREWAY
ON
12
OFF
33•"
25
3" x 4" WIREWAY
1" x 4" WIREWAY
23
90
70
50
110
130
140
CB
30
1" x 4" W I
REW AY
TB1 (32) 1492-J4
1" x 4" W I
REW AY
TB2
1" x 4" W I
REW AY
TB1
CB
41"
2" x 4" W I
REW AY
37"
TB2 (24) 1492-J4-B
1" x 4" WIREWAY
45"
16
15
20
17
22
26
14
21
18
ENCLOSURE:
NEMA 12
48.00"H x 37.38"W x 10.00"D
BACKPANEL LAYOUT
BACKPANEL:
HOFFMAN A-48P36
45.00"H x 33.00"W
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65378
2007
DRAWING NO.
9190A-7-4121
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 12, 48" X 37.38" X 12" FLANGE MOUNTED DISCONNECT
HOFFMAN
MANUFACTURER
A-48SA3812LPPL
PART No.
2
1
BACK PANEL, 45.00" X 33.00"
HOFFMAN
A-48P36
3
3
DRIVE HIM, FULL NUMERIC LCD, POWER FLEX
ALLEN-BRADLEY
20-HIM-A6
4
1
ENCLOSURE, 4" COOLING FAN, W/COMPOSITE GRILLE, NEMA 12
HOFFMAN
TFP41UL12
5
1
ENCLOSURE, 4" EXHAUST GRILLE, NEMA 12
HOFFMAN
TEP41UL12
6
5
PER PRINT/LIST
LEGEND
7
1
DISCONNECT SWITCH, NON FUSED, 125 AMP
ALLEN-BRADLEY
1494V-DN200-C-D-F-G
8
1
DRIVE VFD, 480 VAC, 50 HP, HD, 65A 3PH POWERFLEX 753
ALLEN-BRADLEY
20F11NDO65AAONNNNN
9
2
DRIVE VFD, 380-480 VAC, 2HP, HD, POWERFLEX 753, NEMA 1
ALLEN-BRADLEY
20F11ND3P4AAONNNNN
10
3
I/O BOARD, DRIVE VFD, POWERFLEX 750 CLSS 120VAC, 2 ANA IN, 2 ANA OUT, 6 DI, 2 RO
ALLEN-BRADLEY
20-750-2262D-2R
11
2
ALLEN-BRADLEY
140MG-G8P-B70
12
1
ALLEN-BRADLEY
140MG-G8P-C70
13
1
POWER DISTRIBUTION BLOCK, 1 LINE, 4 LOAD
ALLEN-BRADLEY
1492-PDM3141
14
1
TEMPERTURE SWITCH, 15 AMP
HOFFMAN
ATEMNO
15
1
CIRCUIT BREAKER, 1 POLE, 15 AMP DIN, C-TRIP 120VAC
ALLEN-BRADLEY
1489-M1C150
16
1
CIRCUIT BREAKER, 1 POLE, 5 AMP DIN, C-TRIP
ALLEN-BRADLEY
1489-M1C050
17
30
ALLEN-BRADLEY
1492-J4
18
24
ALLEN-BRADLEY
1492-J4-B
19
8
ALLEN-BRADLEY
1492-EAJ35
20
1
ALLEN-BRADLEY
1492-EBJ3
21
1
ALLEN-BRADLEY
1492-EBJ3-B
22
2
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
23
PHOENIX CONTACT
CD-HF 30X100 3240347
24
PHOENIX CONTACT
CD-HF
60X100 3240355
25
35"
PHOENIX CONTACT
CD-HF 80X100 3240360
26
41"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65378
2007
DRAWING NO.
9190A-7-4122
TB1
H403655
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
A-MCP4120
.
ƒ" x 4•"
•"
WHITE
BLACK
2
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
LINE 2
BLOWER
1" x 3"
‚"
WHITE
BLACK
LINE 2
BLOWER H.E.
1" x 3"
WHITE
BLACK
1
4
1
5
SCALE 2
METERING RAL
‚"
1" x 3"
‚"
WHITE
BLACK
N403655
TB2
412804
415104
412806
415102
SHLD
3
TB1-1
5
AMP
4
TB1-2
15
AMP
3
GND
414844
4
412530
414845
5
414300
5
SHLD
6
414302
6
415110
7
N404100
7
415108
8
414502
8
SHLD
9
1
414304
JOB #9190A
9
414848
10
A-MCP4120
CB & FUSE CHART
1
2
10
480/3/60
414849
11
414306
11
SHLD
12
12
415116
13
414504
14
2
414308
WARNING!
POWER FED FROM
MULTPLE SOURCES
13
415114
14
SHLD
15
15
414852
16
414310
16
414853
17
17
HOLES IN ENCLOSURE
SHLD
18
18
414506
19
19
MUST BE FILLED WITH
20
20
21
21
22
22
414312
3
4
LINE 2
BLOWER
5
LINE 2
BLOWER H.E.
SCALE 2
METERING RAL
23
23
24
24
25
26
27
COPPER WIRE WITH
28
60 DEG C INSULATION
29
30
31
32
33
TERMINAL BLOCK
34
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
TB2
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65378
2007
DRAWING NO.
9190A-7-4123
WIRING LEGEND
- DENOTES PRE-WIRED
402149
00
02CBG4003
1-BK (BR)
REF.
4021-49
0 SP
402150
2-BK (O)
402151
02
3-BK (Y)
04
POWER
DIST.
BLOCK
140MG-G8P-C70
OL
412502-L1
412506A
R
(L1)
06
OL
412502-L2
412507A
OL
412502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
412508A
20F11ND077AA0NNNNN
T
(L3)
08
412506
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4025
UNIT 2 DSI LINE 2
BLOWER
MOTOR
REF.
4301-11
0 SP
50HP, 65.0 FLA
412507
412508
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
REF.
12
415104
Ai0-
02CBA4510
4148-44
2-W
0 SP
TB2-1
415102
20-HIM-A6
31
UNIT 2 DSI LINE 2
BLOWER
SPEED REFERENCE
415102
42
TB2-2
SHLD
2-SH
FACTORY
HIM CABLE
J4
Ai0+
2-BK
14
DPI PORT 1
415104
SHLD
TB2-3
414845
414845
Ao0-
1-W
TB2-4
414844
16
UNIT 2 DSI LINE 2
BLOWER
OUTPUT FREQUENCY
414844
Ao0+
1-BK
REF.
4126-12
TB2-5
SHLD
1-SH
SHLD
TB2
TB2-6
18
R0NC
REF.
4143-01
414300
414300
R0C
02CBD4239
1-BK
X SP
TB1-6
414302
20
UNIT 2 DSI LINE 2
BLOWER
RUNNING SIGNAL
414302
R0NO
4-O
TB1-7
TB3
22
Di 0dc
N404100
N404100
Di C
2-R
TB1-8
414502
24
UNIT 2 DSI LINE 2
BLOWER
RUN COMMAND
414502
Di 0ac
6-BR
TB1-9
REF.
4126-22
20-750-2262D-2R
26
TB2
R0NC
414300
28
R0C
TB1-6
REF.
4126-20
414304
5-Y
R0NO
UNIT 2 DSI LINE 2
BLOWER
FAULTED SIGNAL
R1NC
UNIT 2 DSI LINE 2
BLOWER
HEATER HEATER
414304
TB1-10
REF.
4126-18
30
412530
REF.
4128-06
32
412806
R1C
R1NO
412502-L3
412502-L2
412502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4125
412502-L3
412502-L2
412502-L1
WIRING LEGEND
- DENOTES PRE-WIRED
00
02
04
140MG-G8P-B70
OL
412502-L1
412606A
R
(L1)
06
OL
412502-L2
412607A
OL
412502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
412608A
20F11ND3P4AA0NNNNN
T
(L3)
08
412606
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4026
UNIT 2 DSI LINE 2
MOTOR
REF.
4302-07
0 SP
2HP, 3.4 FLA
412607
412608
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
12
REF.
415110
4125-17
4-W
Ai0TB2-7
415108
20-HIM-A6
31
UNIT 2 DSI LINE 2
SPEED REFERENCE
415108
42
TB2-8
SHLD
4-SH
FACTORY
HIM CABLE
J4
Ai0+
4-BK
14
DPI PORT 1
415110
SHLD
TB2-9
414849
414849
Ao0-
3-W
TB2-10
414848
16
UNIT 2 DSI LINE 2
OUTPUT FREQUENCY
414848
Ao0+
3-BK
REF.
4127-12
TB2-11
SHLD
3-SH
SHLD
TB2
TB2-12
REF.
4125-30
18
R0NC
414300
R0C
TB1-11
REF.
4125-29
20
414306
UNIT 2 DSI LINE 2
RUNNING SIGNAL
414306
R0NO
7-R/BK
TB1-12
TB3
REF.
4125-25
22
Di 0dc
N404100
Di C
TB1-13
414504
24
UNIT 2 DSI LINE 2
RUN COMMAND
414504
Di 0ac
9-O/BK
TB1-14
REF.
4127-22
26
20-750-2262D-2R
TB2
R0NC
414300
28
R0C
TB1-11
REF.
4127-20
414308
UNIT 2 DSI LINE 2
FAULTED SIGNAL
414308
R0NO
8-BL/BK
TB1-15
REF.
4127-18
30
32
412502-L3
412502-L2
412502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4126
412502-L3
412502-L2
412502-L1
WIRING LEGEND
- DENOTES PRE-WIRED
00
02
04
140MG-G8P-B70
OL
412502-L1
412706A
R
(L1)
06
OL
412502-L2
412707A
OL
412502-L3
ALLEN-BRADLEY
POWERFLEX 753
S
(L2)
412708A
20F11ND3P4AA0NNNNN
T
(L3)
08
412706
U
(T1)
1-BK (BR)
V
(T2)
2-BK (O)
W
(T3)
3-BK (Y)
02CBG4027
UNIT 2 DSI SCALE 2
MOTOR
REF.
4308-00
0 SP
2HP, 3.4 FLA
412707
412708
GND
PE
BARE
10
MAIN CONTROL BOARD
TB1
12
REF.
415116
4126-17
6-W
Ai0TB2-13
415114
20-HIM-A6
31
UNIT 2 DSI SCALE 2
SPEED REFERENCE
415114
42
TB2-14
SHLD
6-SH
FACTORY
HIM CABLE
J4
Ai0+
6-BK
14
DPI PORT 1
415116
SHLD
TB2-15
414853
414853
Ao0-
5-W
TB2-16
414852
16
UNIT 2 DSI SCALE 2
OUTPUT FREQUENCY
414852
Ao0+
5-BK
TB2-17
SHLD
5-SH
SHLD
TB2
TB2-18
REF.
4126-30
18
R0NC
414300
R0C
TB1-16
REF.
4126-29
20
414310
UNIT 2 DSI SCALE 2
RUNNING SIGNAL
414310
R0NO
10-Y/BK
TB1-17
TB3
REF.
4126-25
22
Di 0dc
N404100
Di C
TB1-18
414506
24
UNIT 2 DSI SCALE 2
RUN COMMAND
414506
Di 0ac
12-BK/R
TB1-19
20-750-2262D-2R
26
TB2
R0NC
UNIT 2 DSI SCALE 2
FAULTED SIGNAL
414300
28
R0C
TB1-16
414312
414312
R0NO
11-BR/BK
TB1-20
30
32
412502-L3
412502-L2
412502-L1
34
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4127
WIRING LEGEND
- DENOTES PRE-WIRED
REF.
4036-55
00
GND
40
02CBD4114
3-BL
02
CB-412804
412804
04
H403655
N403655
1-BK
2-R
TEMPERATURE
SWITCH
TB1-4
0 SP
42
412804A
5A
TB1-1
N403655
FAN
TB1-3
ENCLOSURE
COOLING
FAN
44
UNIT 2 DSI LINE 2
BLOWER
MOTOR HEATER
46
CB-412806
412806
06
15A
TB1-2
REF.
4125-30
412530
TB1-5
412530
N403655
1-BK
2-R
02CBD4115
REF.
4301-14
0 SP
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4128
60„"
18"
1
A-CP4130
3
4
5
5
6
72"
3
4
ENCLOSURE:
NEMA 12
HOFFMAN A726018FSD
72.06"H x 60.06"W x 18.06"D
BACKPANEL:
HOFFMAN A72P60F1
60.00"H x 56.00"W
A-CP4130 MAIN PLC PANEL
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/16"=1"
c
CATALOG NO.
65379
2007
DRAWING NO.
9190A-7-4130
40
37
39
47
48
TB1 (2) 1492-J6,(1) 1492-JG6 &
CB
CB
CB
CB
44
CB
CB
31
TB4
CB
CB
34
CB
CB
33
SUPPLY
N L
LNK/ACT
F
X
1
LNK/ACT
F
X
2
1
3
5
7
2
4
6
8
TX
BaseFX
100
RX
LNK
102M C
10/100
BaseTX
ACT
POW ER SUPPLY
1756-EN2T
CB
CB
REV
CB
CB
CB
CB
41
38
39
38
21
22
20
23
33
1
26AUG15
0
01JUN15
DATE
19ƒ "
39† "
33‚ "
29ƒ "
26‡ "
42ƒ "
27
56"
49‡ "
14
SPARE
1756-OF6CI
1756-OF6CI
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
1756-I
F6I
16‡ "
13
CB
CB
CB
31
CB
CB
3" x 4" W I
REW AY
32
27
TB5 (144) 1492-J4-B
30
N L
32
SOLA
TB1
10-24-100P
40
POW ER
TB3
SDN
40
V2
15
SUPPLY
V1
8
SOLA
35
110FX2
37
16
2.5-24-100P
- -
39
25
POW ER
CB
+ +
40
1756-PA75
SPARE
1756-OA16
1756-OA16
26
SDN
CB
- -
TB2
1756-OA16
1756-OW 16I
1756-I
A16
1756-I
A16
1756-I
A16
1756-I
A16
1756-I
A16I
1756-EN2T
9ƒ "
6• "
0"
12
27
4" x 4" W I
REW AY
CB
+ +
37
11
28
(20) 1492-J4-B
CB
10
TB4
CB
27
3" x 4" W I
REW AY
CB
28
3" x 4" W I
REW AY
CB
9
27
MVI
56E-MNET
0"
19
8
TB3 (144) 1492-J4
CB
7
4" x 4" W I
REW AY
CB
1756-L75
SUPPLY
16
TB2 (104) 1492-J4
36
POW ER
1756-PA75
24
4" x 4" W I
REW AY
(40) 1492-J4
3" x 4" W I
REW AY
2
26
10"
42
4" x 4" WIREWAY
TB5
41
PANEL AS BUILT
REVISION NOTE
39
CB
29
CB
17
30
18
CB
32
39
45
46
43
4" x 4" WIREWAY
60"
ENCLOSURE:
NEMA 12
HOFFMAN A726018FSD
72.06"H x 60.06"W x 18.06"D
BACKPANEL:
HOFFMAN A72P60F1
60.00"H x 56.00"W
BACKPANEL LAYOUT
JPN
ADH
JSA
ADH
DRAWN
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
OWENSBORO, KY
A. HEUER
DATE
SCALE
10.Feb.15
1/4"=1"
CATALOG NO.
65379
DRAWING NO.
c
2007
9190A-7-4131
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 12, 72" X 60" X 18" TWO DOOR FREE STANDING
HOFFMAN
MANUFACTURER
A-726018FSD
PART No.
2
1
BACK PANEL, 60" X 56" FULL PANEL FREE STANDING 2 DOOR ENCLOSURE
HOFFMAN
A-72P60F1
3
2
LIGHTING PACKAGE, DOOR SWITCH FRAME MOUNTED
HOFFMAN
ALFSWD
4
2
LIGHTING PACKAGE, FLOURESCENT, 18", 120VAC DOOR SWITCH
HOFFMAN
LF120V18
5
2
CONTROL ENCLOSURE, LIGHT BRACKET
NOLTEC
336-14
6
1
PER PRINT/LIST
LEGEND
7
1
PROCESSOR, LOGIX W/32M RAM
ALLEN-BRADLEY
1756-L75
8
2
ETHERNET BRIDGE CLX ETHERNET/IP,
10/100 BRIDGE
ALLEN-BRADLEY
1756-EN2T
9
1
INPUT MODULE, 16 POINT, 79-132 VAC ISOLATED, 36 PIN
ALLEN-BRADLEY
1756-IA16I
10
4
INPUT MODULE, 16 POINT, 120 VAC, 20 PIN
ALLEN-BRADLEY
1756-IA16
11
1
OUTPUT MODULE, 16 POINT, RELAY, NO, ISOLATED, 36 PIN
ALLEN-BRADLEY
1756-OW16
12
3
OUTPUT MODULE, 74-265 VAC, 16 POINT, 20 PIN
ALLEN-BRADLEY
1756-OA16
13
6
INPUT MODULE, ISOLATED ANALOG INPUT 6PTS, 20 PIN
ALLEN-BRADLEY
1756-IF6I
14
2
OUTPUT MODULE, ISOLATED ANALOG OUTPUT CURRENT
ALLEN-BRADLEY
1756-OF6CI
15
1
RECEPTACLE, DUPLEX, 15 AMP, DIN MOUNT
HUBBEL
DRUB15
16
2
POWER SUPPLY, 120/240VAC, 13 AMP FOR CONTROL LOGIX
ALLEN-BRADLEY
1756-PA75
17
1
POWER SUPPLY, 24 VDC, 10 AMP, DIN MOUNT
SOLA
SDN 10-24-100P
18
1
POWER SUPPLY, 2.5 AMP, 24 VDC, DIN MOUNT
SOLA
SDN 2.5-24-100P
19
1
COMMUNICATION MODULE, CONTROL LOGIX MODBUS, MASTER/SLAVE ENHANCED
PROSOFT TECHNOLOGIES
MVI56E-MNETR
20
1
ETHERNET SWITCH, 8 10/100 MPT PORTS, 2 FIBER PORTS, ST CONN
N-TRON
110FX2-ST
21
1
CONVERTER, MEDIA, (1) 10/100 COPPER TO (1) FIBER, ST, CONNECTOR, 24VDC
N-TRON
102MC-ST
22
1
CABLE, ETHERNET, CAT 5E, 3FT PATCH CABLE
BELDEN
3FTCAT5EPATCH
23
2
BELDEN
5FTCAT5EPATCH
24
1
CHASSIS, 13 SLOT, CONTROL LOGIX
ALLEN-BRADLEY
1756-A13
25
1
CHASSIS, 10 SLOT, CONTROL LOGIX
ALLEN-BRADLEY
1756-A10
26
2
FILLER PLATE, CONTROL LOGIX
ALLEN-BRADLEY
1756-N2
27
15
TERMINAL BLOCK, 20 PIN, SCREW CLAMP, LOGIX 5550 I/O, 16 AWG
ALLEN-BRADLEY
1756-TBNH
28
2
TERMINAL BLOCK, 36 PIN, SCREW CLAMP, LOGIX 5550 I/O
ALLEN-BRADLEY
1756-TBCH
29
1
ALLEN-BRADLEY
1489-M1C300
30
7
ALLEN-BRADLEY
1489-M1C100
31
3
ALLEN-BRADLEY
1489-M1C050
32
5
ALLEN-BRADLEY
1489-M1C030
33
17
ALLEN-BRADLEY
1489-M1C020
34
1
ALLEN-BRADLEY
1489-M1C010
35
2
ALLEN-BRADLEY
1492-J6
36
1
TERMINAL BLOCK, GROUNDING
ALLEN-BRADLEY
1492-JG6
37
288
TERMINAL BLOCK, 22-10 AWG, 600 V, 35 AMP
ALLEN-BRADLEY
1492-J4
38
164
ALLEN-BRADLEY
1492-J4-B
39
18
ALLEN-BRADLEY
1492-CJJ6-10
40
21
ALLEN-BRADLEY
1492-EBJ3
41
18
ALLEN-BRADLEY
1492-EBJ3-B
42
15
ALLEN-BRADLEY
1492-EAJ35
43
5
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
44
PHOENIX CONTACT
CD-HF 100X100 3240364
45
203" WIRE DUCT, 3" WD 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 80X100 3240360
46
208" DIN RAIL
ALLEN-BRADLEY
199-DR1
47
4
SOCKET, RELAY, HN TYPE, DIN MNT, 5 BLD
ALLEN-BRADLEY
700-HN121
48
4
RELAY, SPDT, 1 POLE, 1 FORM C, HK TYPE, 10 AMP, 5 BLADE
ALLEN-BRADLEY
700-HK36A1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65379
2007
DRAWING NO.
9190A-7-4132
TB1
TB2
405500
414140
1
TB3
414426
1
N404100
414240
73
TB4
N404100
1
413602
73
2
2
GND
413604
74
2
74
3
413502
413502
4
75
3
75
76
4
76
413504A
5
413510
6
413518
414142
413524A
414143
9
413540
414144
413550
414145
11
12
413552
414146
413600
414147
413640
414148
13
14
15
6
78
6
79
7
79
7
80
8
80
414140
414149
414200
414150
16
9
81
10
82
414300
414152
18
83
84
13
85
86
414340
414153
414400
414154
90
414440
414155
414500
414156
414540
414157
21
414208
93
23
23
25
26
26
414161
414162
29
414164
31
31
414166
33
35
36
24
97
28
43
44
45
45
29
101
29
30
102
30
103
31
103
31
104
32
104
32
46
414342
33
35
101
415016
102
415017
31
103
415022
32
36
104
415023
105
SHLD
106
415028
35
107
413603
415029
108
36
414350
108
414840
413603
109
37
110
38
109
414352
38
110
414354
39
111
39
414356
40
40
414358
41
415044
41
SHLD
42
414362
43
415048
115
43
415050
44
414366
415054
45
117
414853
415056
118
46
414370
118
SHLD
SHLD
119
47
414372
48
116
414852
117
414368
46
115
414849
116
47
114
414848
414364
45
113
SHLD
114
44
112
414845
113
414360
414300
415042
112
42
111
414844
119
414856
415060
120
48
N404100
120
413603
49
49
121
50
50
122
415062
49
121
414862
415066
50
122
413603
51
51
123
52
52
124
53
53
125
54
54
126
415068
51
123
SHLD
SHLD
52
124
414868
415072
53
125
413603
415074
54
414408
55
SHLD
29
30
107
414407
413526
100
414828
414406
413524
99
415013
28
33
414405
53
98
415012
34
414404
54
26
27
SHLD
414403
51
97
415009
413603
414348
37
48
52
25
106
414346
414472
414402
96
415008
105
414344
34
414470
50
95
SHLD
414822
414468
47
23
24
413603
414466
46
94
415005
414816
414464
47
93
415004
SHLD
101
102
414462
43
21
22
414813
414460
44
90
415000
25
100
414458
41
42
18
414808
28
414456
N404100
89
414969
SHLD
100
414454
41
88
414968
414812
40
49
23
96
26
39
48
95
27
414452
42
SHLD
16
17
414805
99
38
40
87
414804
98
414450
414173
15
21
26
36
39
86
414963
22
413604
27
414448
414172
85
414962
91
99
37
38
13
14
92
98
414446
414171
84
414957
414809
414444
414170
83
414956
12
20
414340
25
35
37
SHLD
11
414756
20
414532
414442
414169
SHLD
92
93
23
34
414168
82
19
94
24
33
414167
34
81
414953
19
414232
32
9
10
91
414230
414165
32
413603
80
414952
414800
414228
30
415000
79
414949
8
18
414226
29
414163
30
414752
413603
414224
28
413603
414768
414222
27
28
17
414220
414160
27
16
89
414530
N404100
97
414900
414940
SHLD
88
414528
414272
96
25
414159
21
22
95
414218
78
414948
414526
414270
414216
24
414158
6
7
414524
414268
94
414214
414748
77
SHLD
15
90
20
414266
414212
22
24
414264
414840
76
5
413603
414522
19
92
414210
21
22
18
SHLD
414945
414762
414520
414262
91
14
414518
414260
414206
13
86
414516
17
414800
75
414944
413603
85
87
16
414258
414204
413603
414514
414256
20
74
4
415100
414512
15
89
19
20
13
14
88
414202
11
12
414510
414254
413603
415040
83
84
414508
414252
87
9
10
414506
11
12
414250
14
81
82
414504
414248
18
19
9
10
414246
11
12
16
414151
414502
414244
17
414240
8
414242
414744
414740
5
78
414200
15
17
413502
77
414400
8
413520
10
N404100
5
414432
7
8
413540
413610
77
6
413516
73
2
3
413644
4
414400
7
1
413610
3
413642
414430
5
414940
2
414429
4
414740
413606
414428
3
405500
TB5
413604
1
414427
126
414900
55
55
413603
127
55
127
128
56
128
129
57
414409
56
413528
56
414410
57
413530
56
414302
57
414411
58
414304
58
414412
59
59
59
61
61
414415
63
61
63
414417
64
414419
414421
68
69
414423
414424
68
140
414923
415128
141
69
141
SHLD
SHLD
70
414570
142
414928
415132
143
71
414572
72
415126
142
71
414332
139
414922
414568
414330
72
138
415122
67
140
69
71
414425
415120
66
414917
414566
70
137
414916
139
414564
414328
70
65
138
68
136
SHLD
137
414562
414326
135
415116
64
SHLD
414560
414324
414422
63
414913
136
67
134
415114
135
66
414322
133
415110
62
414912
414558
414320
67
61
413603
414556
65
66
414420
133
63
132
415108
134
64
131
SHLD
60
414908
414554
414318
65
59
SHLD
414552
414316
64
414418
131
62
414314
130
415104
132
414550
414312
62
414416
415102
58
414905
414548
60
414310
129
414904
130
414546
414308
60
414414
62
414544
58
414306
414413
60
414542
57
143
413603
415134
144
72
144
TERMINAL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65379
2007
DRAWING NO.
9190A-7-4133
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-CP4130
.
ƒ" x 4•"
•"
WHITE
BLACK
CB & FUSE CHART
1
A-CP4130
TB1-4
30
AMP
TB1-5
3
AMP
TB1-6
3
AMP
TB1-7
10
AMP
TB1-8
10
AMP
TB1-9
10
AMP
TB1-10
10
AMP
TB1-11
10
AMP
TB1-12
3
AMP
TB1-13
3
AMP
TB1-14
5
AMP
TB1-15
1
TB1-16 - TB1-24
AMP
2
AMP
TB4-1
10
AMP
TB4-2
3
AMP
TB4-3
5
AMP
TB4-4
5
AMP
TB4-5 - TB4-12
2
AMP
JOB #9190A
120/1/60
HOLES IN ENCLOSURE
MUST BE FILLED WITH
COPPER WIRE WITH
60 DEG C INSULATION
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
TB2
TB3
TB4
TB5
LEGENDS
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65379
2007
DRAWING NO.
9190A-7-4134
413502
N404100
WIRING LEGEND
- DENOTES PRE-WIRED
CB-413540
GND
REF.
4055-00
00
413502
40
02CBD4150
3-BL
TB1-3
0 SP
POWER FOR
DIGITAL INPUT &
OUTPUT CARDS
413540
10A
TB1-11
N404100
TB1-29
120VDC POWER
TO DIGITAL
INPUTS & OUTPUTS
CB-413502
413502
02
405500
30A
TB1-4
TB1-1
CB-413504
413502
04
413504A
405500
N404100
1-BK
2-R
DOOR
SWITCH
N404100
42
TB1-2
413504
N404100
3A
TB1-5
W
TB1-25
N404100
06
W
TB1-25
ENCLOSURE
LIGHT
44
ENCLOSURE
LIGHT
46
08
48
CB-413510
413502
10
CB-413550
413510
N404100
3A
TB1-6
TB1-26
PROGRAMMING
RECEPTACLE
413502
50
413550
3A
TB1-12
H
ALLEN-BRADLEY
1756-PA75
POWER SUPPLY
N404100
N
TB1-29
G
CONTROL LOGIX
RACK A
POWER SUPPLY
CB-413552
413502
12
52
14
413552
3A
TB1-13
H
ALLEN-BRADLEY
1756-PA75
POWER SUPPLY
N404100
N
TB1-30
G
CONTROL LOGIX
RACK B
POWER SUPPLY
54
CB-413516
413502
16
10A
TB1-7
413516
N404100
1-BK
2-R
N404100
TB1-26
GND
X SP
413502
18
10A
TB1-8
413518
N404100
1-BK
2-R
N404100
TB1-27
GND
X SP
413502
20
10A
TB1-9
413520
N404100
1-BK
2-R
120VAC POWER TO
A-CP4170 SILO
MARSHALLING CABINET
58
120VAC POWER TO
A-PDP4070 HEAT TRACE
DISTRIBUTION PANEL
60
REF.
4175-00
02CBD4152
3-BL
CB-413520
56
REF.
4165-00
02CBD4151
3-BL
CB-413518
120VAC POWER TO
A-CP4160 TRUCK
UNLOAD PANEL
N404100
TB1-27
GND
REF.
4076-00
02CBD4116
3-BL
X SP
22
62
CB-413524
413502
24
CR414430
413524A
10A
TB1-10
413524
413524
N404100
TB1-55
1-BK
2-R
N404100
TB1-28
GND
413524A
X SP
413526
413526
N404100
TB1-56
1-BK
2-R
26
N404100
TB1-28
GND
413524A
413528
28
TB1-57
X SP
413528
N404100
1-BK
2-R
N404100
TB1-31
GND
413530
30
TB1-58
66
120VAC POWER TO
BLOWER BUILDING
LOUVER 1
68
120VAC POWER TO
BLOWER BUILDING
LOUVER 2
70
REF.
4300-22
3-BL
CR414428
413524A
120VAC POWER TO
BLOWER BUILDING
EXHAUST FAN 2
REF.
4300-25
02CBD4213
3-BL
CR414426
64
REF.
4300-21
02CBD4212
3-BL
CR414432
120VAC POWER TO
BLOWER BUILDING
EXHAUST FAN 1
X SP
413530
N404100
1-BK
2-R
N404100
TB1-31
GND
REF.
4300-26
3-BL
X SP
32
72
34
74
413502
N404100
413502
N404100
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4135
413502
N404100
413502
N404100
WIRING LEGEND
- DENOTES PRE-WIRED
CB-413600
413502
00
CB-413640
413600
N404100
413502
40
5A
TB1-14
413640
N404100
1A
TB1-15
L N G
L N G
SOLA/HEVI DUTY
24VDC POWER
SUPPLY
POWER SUPPLY
24 VDC
10 AMP
02
04
42
+ -
CB-413604
413604
+ -
CB-413644
413602
413603
413644
44
10A
TB4-1
SOLA/HEVI DUTY
24VDC POWER
SUPPLY
POWER SUPPLY
24 VDC
2.5 AMP
413642
413643
5A
TB4-4
TB4-13
CB-413606
413604
06
413606
3A
TB4-2
+
NTRON
MEDIA
CONVERTER
413603
G
TB4-13
N-TRON
MEDIA
CONVERTER
08
413644
46
+
NTRON
ETHERNET
SWITCH
413643
G
N-TRON
ETHERNET
SWITCH
48
CB-413610
413604
10
413610
5A
TB4-3
POWER FOR
ANALOG INPUT &
OUTPUT CARDS
413603
TB4-14
24VDC POWER
FOR ANALOG
INPUTS & OUTPUTS
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
413604
413603
24VDC POWER DISTRIBUTION
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4136
WIRING LEGEND
- DENOTES PRE-WIRED
ALLEN-BRADLEY #1756-L75
PROCESSOR
RACK A, SLOT 0
00
02
42
04
44
06
46
1756-L75
1756-EN2T
LOGIX5555
ETHERNET/IP
08
ALLEN-BRADLEY #1756-ENT2
ETHERNET MODULE
RACK A, SLOT 1
40
48
10/100 BASE T
10
50
RUN
FORCE
SD
OK
12
LINK
NET
OK
52
O
R
P
G
R
U
N
REM
14
54
SD
16
56
18
58
USB
PORT
!
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
RJ45 CABLE
CONNECTOR
LOCATED ON
UNDERSIDE OF
MODULE
I/O WIRING DIAGRAM, RACK A SLOTS 0 & 1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4140
413540
N404100
40
2A
TB1-16
PROSOFT MVI56E-MNET
MODBUS TCP/IP MODULE
RACK A, SLOT 2
00
CB-414140
WIRING LEGEND
- DENOTES PRE-WIRED
1756-IA16I
414140
02
414142
42
TB2-1
TB2-9
A:03:I.00
1 IN-0
DATA[3].00
ALLEN-BRADLEY #1756-IA16I
120VAC ISOLATED INPUT
RACK A, SLOT 3
SPARE
INPUT
414143
2
L2-0
TB2-10
414144
04
44
TB2-11
A:03:I.01
3 IN-1
DATA[3].01
SPARE
INPUT
414143
4
L2-1
TB2-12
414140
06
414146
46
TB2-2
TB2-13
A:03:I.02
5 IN-2
DATA[3].02
SPARE
INPUT
414145
6
MVI56E-MNET
L2-2
TB2-14
MODBUS TCP/IP
08
414148
48
TB2-15
A:03:I.03
7 IN-3
DATA[3].03
SPARE
INPUT
414149
8
L2-3
TB2-16
414140
10
414150
50
TB2-3
TB2-17
A:03:I.04
9 IN-4
DATA[3].04
SPARE
INPUT
414151
10 L2-4
TB2-18
ERR
APP
OK
12
414152
52
TB2-19
A:03:I.05
11 IN-5
DATA[3].05
SPARE
INPUT
414153
12 L2-5
TB2-20
414140
14
414154
54
TB2-4
TB2-21
A:03:I.06
13 IN-6
DATA[3].06
SPARE
INPUT
414153
14 L2-6
TB2-22
10/100
414156
16
E1
56
TB2-23
LINK/ACT
A:03:I.07
15 IN-7
DATA[3].07
SPARE
INPUT
414157
16 L2-7
CONFIG
TB2-24
RESET
18
414140
414158
58
TB2-5
TB2-25
A:03:I.08
17 IN-8
DATA[3].08
SPARE
INPUT
414159
18 L2-8
TB2-26
414160
20
60
TB2-27
A:03:I.09
19 IN-9
DATA[3].09
SPARE
INPUT
414161
20 L2-9
TB2-28
414140
22
414162
62
TB2-6
TB2-29
A:03:I.10
21 IN-10
DATA[3].10
SPARE
INPUT
414163
22 L2-10
TB2-30
414164
24
64
TB2-31
A:03:I.11
23 IN-11
DATA[3].11
SPARE
INPUT
414165
24 L2-11
TB2-32
414140
26
414166
66
TB2-7
TB2-33
A:03:I.12
25 IN-12
DATA[3].12
SPARE
INPUT
414167
26 L2-12
TB2-34
414168
28
68
TB2-35
A:03:I.13
27 IN-13
DATA[3].13
SPARE
INPUT
414169
28 L2-13
TB2-36
414140
30
414170
70
TB2-8
TB2-37
A:03:I.14
29 IN-14
DATA[3].14
SPARE
INPUT
414171
30 L2-14
TB2-38
414172
32
72
TB2-39
A:03:I.15
31 IN-15
DATA[3].15
SPARE
INPUT
414173
32 L2-15
TB2-40
34
L2-1534
74
33,35,36
NOT USED
N404100
414140
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4141
413540
N404100
413540
N404100
REF.
4300-02
02CBD4215
X SP
414200
02
TB2-81
414200
414202
1-BK
4-O
414202
TB2-89
414204
04
5-Y
414200
414204
TB2-90
414206
06
6-BR
TB2-82
414206
TB2-91
414208
08
7-R/BK
REF.
4300-12
414208
TB2-92
10
TB2-83
REF.
4302-24
414200
414210
1-BK
2-R
414210
TB2-93
12
TB2-83
REF.
4302-27
414200
414212
1-BK
2-R
414212
TB2-94
14
TB2-84
REF.
4300-30
414200
414214
1-BK
2-R
414214
TB2-95
TB2-84
X SP
A:04:I.00
1
DATA[4].00
UNIT 2 DSI
AIR COMPRESSOR 1
RUNNING
42
A:04:I.01
2
DATA[4].01
UNIT 2 DSI
AIR COMPRESSOR 1
FAULTED
44
A:04:I.02
3
DATA[4].02
UNIT 2 DSI
AIR COMPRESSOR 1
LOADED
46
A:04:I.03
4
DATA[4].03
UNIT 2 DSI
AIR COMPRESSOR 1
GENERAL FAULT
48
A:04:I.04
5
DATA[4].04
UNIT 2 DSI
AIR COMPRESSOR 1
DRYER FAULT
50
A:04:I.05
6
DATA[4].05
UNIT 2 T.U. DEHUMIDIFIER
EVAPORATOR INLET AIR
TEMPERATURE SWITCH
52
A:04:I.06
7
DATA[4].06
EVAPORATOR OUTLET AIR
TEMPERATURE SWITCH
54
A:04:I.07
8
DATA[4].07
L2-0 9
L2-0 10
UNIT 2 BLOWER BUILDING
EXHAUST
THERMOSTAT
56
414240
TB3-1
414240
414242
1-BK
4-O
414244
5-Y
414240
414200
414216
1-BK
2-R
414216
TB2-96
414200
414218
18
TB2-85
TB2-97
414220
20
TB2-98
414200
414222
22
TB2-86
TB2-99
414224
24
TB2-100
TB2-87
414200
414226
1-BK
4-O
414226
TB2-101
414228
28
5-Y
414200
TB2-88
414228
TB2-102
414230
6-BR
414230
TB2-103
414232
32
414244
A:05:I.01
2
DATA[5].01
UNIT 2 SILO LINE 1
BLOWER
FAULTED SIGNAL
414246
A:05:I.02
3
DATA[5].02
UNIT 2 DSI SILO LINE 1
RUNNING SIGNAL
414248
A:05:I.03
4
DATA[5].03
FAULTED SIGNAL
A:05:I.04
5
DATA[5].04
UNIT 2 DSI SILO SCALE 1
RUNNING SIGNAL
414252
A:05:I.05
6
DATA[5].05
FAULTED SIGNAL
414254
A:05:I.06
7
DATA[5].06
SPARE
INPUT
414256
A:05:I.07
8
DATA[5].07
L2-0 9
L2-0 10
414246
TB3-11
414248
8-BL/BK
414240
TB3-12
414250
10-Y/BK
TB3-3
414250
TB3-13
414252
11-BR/BK
TB3-14
414240
TB3-4
TB3-15
TB3-16
REF.
4309-02
REF.
4144-57
02CBD4233
X SP
A:04:I.08
11
DATA[4].08
SPARE
INPUT
58
A:04:I.09
12
DATA[4].09
SPARE
INPUT
60
A:04:I.10
13
DATA[4].10
SPARE
INPUT
62
414240
TB3-5
414240
414258
1-BK
4-O
414240
A:05:I.09
12
DATA[5].09
UNIT 2 DSI CONVERGING
2-WAY SWITCH
POS. 2 PROXIMITY SWITCH
414262
A:05:I.10
13
DATA[5].10
2-WAY SWITCH
SEALED PRESSURE SWITCH
414264
A:05:I.11
14
DATA[5].11
UNIT 2 T.U. BLOWER
DSI ISOLATION VALVE
CLOSED LIMIT SWITCH
414266
A:05:I.12
15
DATA[5].12
UNIT 2 T.U. BLOWER
DSI ISOLATION VALVE
OPEN LIMIT SWITCH
A:05:I.13
16
DATA[5].13
SPARE
INPUT
414270
A:05:I.14
17
DATA[5].14
UNIT 2 T.U. BLOWER
RUNNING
SIGNAL
414272
A:05:I.15
18
DATA[5].15
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
RUNNING SIGNAL
414260
TB3-18
414262
6-BR
TB3-6
2-WAY SWITCH
POS. 1 PROXIMITY SWITCH
TB3-17
5-Y
TB3-19
REF.
4144-49
X SP
A:04:I.11
14
DATA[4].11
SPARE
INPUT
64
A:04:I.12
15
DATA[4].12
UNIT 2 HEAT TRACE
CIRCUIT 1
ON SIGNAL
66
A:04:I.13
16
DATA[4].13
UNIT 2 HEAT TRACE
CIRCUIT 2
ON SIGNAL
68
414240
TB3-6
7-R/BK
414240
414264
1-BK
4-O
TB3-20
414240
414266
414232
TB2-104
5-Y
TB3-7
TB3-21
414268
TB3-22
REF.
4144-69
02CBD4237
X SP
A:04:I.14
17
DATA[4].14
UNIT 2 HEAT TRACE
CIRCUIT 3
ON SIGNAL
70
A:04:I.15
18
DATA[4].15
AMBIENT TEMPERATURE
BELOW 35°
SIGNAL
72
414240
TB3-8
414240
TB3-8
414240
414270
1-BK
4-O
TB3-23
414272
5-Y
TB3-24
L2-1 19
34
L2-1 19
74
L2-1 20
414200
SPARE
INPUT
A:05:I.08
11
DATA[5].08
414258
414260
REF.
4105-09
30
UNIT 2 SILO LINE 1
BLOWER
RUNNING SIGNAL
02CBD4222
X SP
414200
26
A:05:I.00
1
DATA[5].00
TB3-10
7-R/BK
TB3-2
REF.
????-??
REF.
4076-40
414242
TB3-9
02CBD4211
X SP
414200
16
REF.
4144-41
02CBD4228
02CBD4218
X SP
414200
REF.
4115-19
02CBD4217
X SP
414200
1756-IA16
ALLEN-BRADLEY #1756-IA16
120VAC INPUT MODULE
RACK A, SLOT 5
02CBD4216
X SP
414200
40
2A
TB1-18
1756-IA16
120VAC INPUT MODULE
RACK A, SLOT 4
CB-414240
2A
TB1-17
00
CB-414200
WIRING LEGEND
- DENOTES PRE-WIRED
N404100
L2-1 20
N404100
414240
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4142
413540
N404100
413540
N404100
REF.
4125-19
02CBD4239
REF.
4145-01
X SP
414300
414300
02
TB3-49
414302
1-BK
4-O
414302
TB3-57
414304
04
5-Y
414300
414304
TB3-58
414306
06
7-R/BK
TB3-50
414306
TB3-59
414308
08
8-BL/BK
414300
414308
TB3-60
414310
10
10-Y/BK
TB3-51
414310
TB3-61
414312
12
11-BR/BK
REF.
4176-00
02CBD4242
414312
TB3-62
14
TB3-52
414300
414314
1-BK
4-O
5-Y
414300
TB3-63
414316
TB3-64
414318
18
6-BR
TB3-53
414318
TB3-65
414320
20
TB3-66
414300
414322
22
TB3-54
TB3-67
REF.
????-??
TB3-54
414300
414324
1-BK
4-O
414300
414324
TB3-68
414326
26
5-Y
TB3-55
REF.
4177-00
02CBD4248
414326
TB3-69
414300
TB3-55
414300
30
TB3-56
414300
414328
1-BK
4-O
A:06:I.01
2
DATA[6].01
UNIT 2 SILO LINE 2
BLOWER
FAULTED SIGNAL
44
A:06:I.02
3
DATA[6].02
RUNNING SIGNAL
46
A:06:I.03
4
DATA[6].03
FAULTED SIGNAL
48
A:06:I.04
5
DATA[6].04
RUNNING SIGNAL
50
A:06:I.05
6
DATA[6].05
FAULTED SIGNAL
52
A:06:I.06
7
DATA[6].06
UNIT 2 DSI SILO
EMERGENCY HIGH
LEVEL PROBE
54
A:06:I.07
8
DATA[6].07
L2-0 9
L2-0 10
UNIT 2 DSI SILO
HIGH
LEVEL PROBE
56
A:06:I.08
11
DATA[6].08
UNIT 2 DSI SILO
MID
LEVEL PROBE
58
A:06:I.09
12
DATA[6].09
SPARE
INPUT
60
A:06:I.10
13
DATA[6].10
SPARE
INPUT
62
A:06:I.11
14
DATA[6].11
UNIT 2 T.U. BLOWER
ACI ISOLATION VALVE
CLOSED LIMIT SWITCH
64
A:06:I.12
15
DATA[6].12
UNIT 2 T.U. BLOWER
ACI ISOLATION VALVE
OPEN LIMIT SWITCH
66
A:06:I.13
16
DATA[6].13
EMERGENCY HIGH
LEVEL PROBE
68
A:06:I.14
17
DATA[6].14
LOW
LEVEL PROBE
70
A:06:I.15
18
DATA[6].15
ZERO SPEED SWITCH
72
TB3-97
414340
414342
1-BK
2-R
4-O
414340
5-Y
UNIT 2 DSI SILO
DUST COLLECTOR "AUTO"
SELECTOR SWITCH
A:07:I.02
3
DATA[7].02
UNIT 2 DSI SILO
TRUCK UNLOAD ALARM SILENCE
PUSH BUTTON
A:07:I.03
4
DATA[7].03
UNIT 2 T.U. BLOWER
START
PUSH BUTTON
A:07:I.04
5
DATA[7].04
UNIT 2 T.U. BLOWER
STOP
PUSH BUTTON
414352
A:07:I.05
6
DATA[7].05
UNIT 2 DSI SILO
TRUCK FILL LINE CONNECTED
LIMIT SWITCH
414354
A:07:I.06
7
DATA[7].06
UNIT 2 DSI SILO
PANT LEG 1 LOW
LEVEL PROBE
A:07:I.07
8
DATA[7].07
L2-0 9
L2-0 10
UNIT 2 DSI SILO
PANT LEG 2 LOW
LEVEL PROBE
A:07:I.08
11
DATA[7].08
UNIT 2 DSI SILO
DISCHARGE VALVE SCALE 1
CLOSED LIMIT SWITCH
A:07:I.09
12
DATA[7].09
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414362
A:07:I.10
13
DATA[7].10
UNIT 2 DSI SILO
CLOSED LIMIT SWITCH
414364
A:07:I.11
14
DATA[7].11
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414366
A:07:I.12
15
DATA[7].12
SPARE
INPUT
A:07:I.13
16
DATA[7].13
EMERGENCY HIGH
LEVEL PROBE
414370
A:07:I.14
17
DATA[7].14
LOW
LEVEL PROBE
414372
A:07:I.15
18
DATA[7].15
ZERO SPEED SWITCH
414346
TB3-107
6-BR
414348
TB3-108
414350
7-R/BK
TB3-99
A:07:I.01
2
DATA[7].01
414344
414348
414340
UNIT 2 DSI SILO
DUST COLLECTOR "HAND"
SELECTOR SWITCH
TB3-106
414346
TB3-98
A:07:I.00
1
DATA[7].00
414342
TB3-105
414344
414350
TB3-109
414352
8-BL/BK
TB3-110
02CBD4252
X SP
414340
TB3-100
414340
414354
1-BK
4-O
TB3-111
414356
5-Y
414340
414356
TB3-112
414358
6-BR
TB3-101
414358
TB3-113
414360
7-R/BK
414340
414360
TB3-114
414362
8-BL/BK
TB3-102
TB3-115
414364
9-O/BK
TB3-70
414330
5-Y
414330
TB3-71
6-BR
414332
TB3-72
TB3-116
414340
TB3-103
REF.
4177-40
414328
414332
32
42
414340
REF.
4145-23
X SP
28
UNIT 2 SILO LINE 2
BLOWER
RUNNING SIGNAL
TB3-117
REF.
4145-63
02CBD4254
X SP
414340
TB3-103
414340
TB3-104
414340
414368
1-BK
4-O
414368
TB3-118
414370
5-Y
TB3-119
414372
6-BR
TB3-120
L2-1 19
34
L2-1 19
74
L2-1 20
414300
02CBD4249
X SP
A:06:I.00
1
DATA[6].00
120VAC INPUT MODULE
RACK A, SLOT 7
REF.
4145-09
X SP
414300
24
REF.
4165-40
REF.
4176-40
414314
414316
16
1756-IA16
REF.
4145-07
X SP
414300
40
2A
TB1-20
1756-IA16
120VAC INPUT MODULE
RACK A, SLOT 6
CB-414340
2A
TB1-19
00
CB-414300
WIRING LEGEND
- DENOTES PRE-WIRED
N404100
L2-1 20
N404100
414340
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4143
413540
N404100
413540
N404100
414402
DATA[8].00
TB2-49
414403
40
SPARE
OUTPUT
42
SPARE
OUTPUT
44
SPARE
OUTPUT
46
2A
TB1-22
1756-OW16I
A:08:O.00
1
02
ALLEN-BRADLEY #1756-OW16I
120VAC ISOLATED OUTPUT
RACK A, SLOT 8
CB-414440
2A
TB1-21
00
CB-414400
WIRING LEGEND
- DENOTES PRE-WIRED
ALLEN-BRADLEY #1756-OA16
120VAC OUTPUT MODULE
RACK A, SLOT 9
1756-OA16
REF.
4142-41
A:09:O.00
1
414442
DATA[9].00
TB3-33
414442
N404100
6-BR
2-R
N404100
TB3-25
UNIT 2 SILO LINE 1
BLOWER
RUN COMMAND
N404100
2 L1-0
TB2-50
A:08:O.01
3
04
TB2-41
414404
DATA[8].01
TB2-51
A:09:O.01
2
414444
DATA[9].01
RUN COMMAND
414444
TB3-34
9-O/BK
414405
4 L1-1
TB2-52
A:08:O.02
5
06
414406
DATA[8].02
TB2-53
414407
A:09:O.02
3
414446
DATA[9].02
414446
TB3-35
N404100
12-BK/R
TB3-26
N404100
6 L1-2
A:08:O.03
7
08
REF.
4302-35
02CBD4205
TB2-54
TB2-42
414408
DATA[8].03
SPARE
OUTPUT
TB2-55
A:09:O.03
4
48
X SP
414448
DATA[9].03
TB3-36
RUN COMMAND
414448
N404100
1-BK
2-R
N404100
TB3-26
UNIT 2 T.U. BLOWER
DEHUMIDIFIER
PERMISSIVE
414409
REF. 4142-63
8 L1-3
TB2-56
A:08:O.04
9
10
414410
DATA[8].04
SPARE
OUTPUT
TB2-57
414411
A:09:O.04
5
50
414450
DATA[9].04
TB3-37
414450
N404100
6-BR
2-R
N404100
TB3-27
UNIT 2 T.U. BLOWER
DSI ISOLATION VALVE
OPEN SOLENOID
N404100
10 L1-4
TB2-58
A:08:O.05
11
12
TB2-43
414412
SPARE
DATA[8].05
TB2-59
OUTPUT
52
SPARE
OUTPUT
54
SPARE
OUTPUT
56
A:09:O.05
6
414452
DATA[9].05
UNIT 2 T.U. BLOWER
DSI ISOLATION VALVE
CLOSED SOLENOID
414452
TB3-38
7-R/BK
414413
12 L1-5
TB2-60
A:08:O.06
13
14
414414
DATA[8].06
TB2-61
414415
A:09:O.06
7
414454
DATA[9].06
N404100
TB3-39
TB3-28
SPARE
OUTPUT
N404100
14 L1-6
TB2-62
A:08:O.07
15
16
TB2-44
414416
DATA[8].07
TB2-63
A:09:O.07
8
414456
DATA[9].07
L2-0 9
L1-0 10
414417
16 L1-7
SPARE
OUTPUT
TB3-40
REF. 4142-57
TB2-64
A:08:O.08
17
18
414418
DATA[8].08
TB2-65
414419
SPARE
OUTPUT
58
SPARE
OUTPUT
60
SPARE
OUTPUT
62
SPARE
OUTPUT
64
UNIT 2 DSI BLOWER BUILDING
LOUVER 1
START RELAY
4135-28
66
LOUVER 2
START RELAY
4135-30
68
A:09:O.08
11
414458
DATA[9].08
414458
N404100
TB3-41
7-R/BK
2-R
TB3-42
8-BL/BK
TB3-43
9-O/BK
TB3-44
10-Y/BK
N404100
TB3-29
2-WAY SWITCH
POS. 1 SOLENOID
N404100
18 L1-8
TB2-66
A:08:O.09
19
20
TB2-45
414420
DATA[8].09
TB2-67
A:09:O.09
12
414460
DATA[9].09
2-WAY SWITCH
POS. 2 SOLENOID
414460
414421
20 L1-9
TB2-68
A:08:O.10
21
22
414422
DATA[8].10
TB2-69
414423
A:09:O.10
13
414462
DATA[9].10
414462
N404100
TB3-30
2-WAY SWITCH
SEAL SOLENOID
N404100
22 L1-10
TB2-70
A:08:O.11
23
24
TB2-46
414424
DATA[8].11
TB2-71
A:09:O.11
14
414464
DATA[9].11
2-WAY SWITCH
UNSEAL SOLENOID
414464
414425
24 L1-11
TB2-72
A:08:O.12
25
26
DATA[8].12
414426
CR414426
414426
N404100
414400 TB2-73
TB2-47
414427
A:09:O.12
15
414466
DATA[9].12
N404100
TB3-45
TB3-31
SPARE
OUTPUT
26 L1-12
TB2-74
A:08:O.13
27
28
DATA[8].13
414428
CR414428
414428
N404100
414400 TB2-75
TB2-47
414429
A:09:O.13
16
414468
DATA[9].13
SPARE
OUTPUT
TB3-46
REF.
4142-69
28 L1-13
TB2-76
A:08:O.14
29
30
DATA[8].14
414430
CR414430
414430
N404100
414400 TB2-77
TB2-48
414400
EXHAUST FAN 1
START RELAY
4135-24
70
EXHAUST FAN 2
START RELAY
4135-26
72
A:09:O.14
17
414470
DATA[9].14
TB3-47
414470
N404100
6-BR
2-R
N404100
TB3-32
UNIT 2 T.U. BLOWER
MOTOR
STARTER
30 L1-14
TB2-78
A:08:O.15
31
32
DATA[8].15
414432
CR414432
414432
414400 TB2-79
414400
N404100
TB2-48
A:09:O.15
18
DATA[9].15
414472
414472
TB3-48
N404100
7-R/BK
TB3-32
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
MOTOR STARTER
32 L1-15
34 L1-15
TB2-80
L2-1 19
34
74
33,35,36
NOT USED
414400
N404100
L1-1 20
N404100
414440
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4144
413540
413540
N404100
N404100
REF.
4143-01
414502
DATA[12].00
A:10:O.01
2
04
TB3-81
414504
DATA[12].01
A:10:O.02
3
06
40
N404100
6-BR
2-R
N404100
TB3-73
414504
TB3-82
414506
DATA[12].02
414502
N404100
9-O/BK
TB3-73
414506
TB3-83
N404100
12-BK/R
TB3-74
UNIT 2 SILO LINE 2
BLOWER
RUN COMMAND
42
RUN COMMAND
44
RUN COMMAND
46
UNIT 2 DSI SILO
DUST COLL. TIMER BOARD
START RELAY
48
UNIT 2 T.U. BLOWER
ACI ISOLATION VALVE
OPEN SOLENOID
50
UNIT 2 T.U. BLOWER
ACI ISOLATION VALVE
CLOSED SOLENOID
52
SPARE
OUTPUT
54
UNIT 2 DSI SILO
OPEN SOLENOID
56
UNIT 2 DSI SILO
OPEN SOLENOID
58
UNIT 2 DSI SILO
FLUIDIZING BIN 1
SOLENOID
60
UNIT 2 DSI SILO
FLUIDIZING BIN 2
SOLENOID
62
2A
TB1-24
1756-OA16
A:10:O.00
1
02
RACK A, SLOT 10
CB-414540
2A
TB1-23
00
CB-414500
WIRING LEGEND
- DENOTES PRE-WIRED
1756-OA16
X SP
414542
DATA[13].00
A:11:O.01
2
TB3-129
414544
DATA[13].01
A:11:O.02
3
414546
DATA[13].02
414542
N404100
1-BK
2-R
N404100
TB3-121
4-O
414546
TB3-131
UNIT 2 DSI SILO
DUST COLLECTOR ON
PILOT LIGHT
UNIT 2 DSI SILO
PILOT LIGHT
414544
TB3-130
REF.
4165-56
02CBD4281
A:11:O.00
1
RACK A, SLOT 11
N404100
5-Y
TB3-122
UNIT 2 DSI SILO
EMERGENCY HIGH LEVEL
PILOT LIGHT
REF.
4143-13
A:10:O.03
4
08
414508
DATA[12].03
TB3-84
414508
N404100
7-R/BK
2-R
N404100
TB3-74
A:11:O.03
4
414548
DATA[13].03
UNIT 2 DSI SILO
HIGH LEVEL
PILOT LIGHT
414548
TB3-132
6-BR
REF. 4143-23
A:10:O.04
5
10
414510
DATA[12].04
A:10:O.05
6
12
TB3-85
414512
DATA[12].05
A:10:O.06
7
14
414510
N404100
6-BR
2-R
414512
TB3-86
7-R/BK
414514
DATA[12].06
N404100
TB3-87
TB3-76
02CBD4282
A:10:O.07
8
16
A:10:O.08
11
TB3-88
414518
DATA[12].08
A:10:O.09
12
20
A:10:O.10
13
22
414520
2-R
N404100
TB3-76
N404100
5-Y
TB3-77
414520
TB3-90
6-BR
TB3-91
7-R/BK
414522
DATA[12].10
N404100
4-O
414518
TB3-89
DATA[12].09
414516
414522
A:11:O.04
5
414550
DATA[13].04
A:11:O.05
6
DATA[13].05
A:11:O.06
7
414550
TB3-133
414552
TB3-123
414554
8-R/BK
414554
TB3-135
N404100
9-O/BK
TB3-124
N404100
TB3-78
A:11:O.07
8
414556
24
414524
DATA[12].11
A:10:O.12
15
26
A:10:O.13
16
A:10:O.14
17
A:10:O.15
18
DATA[12].15
TB3-93
8-BL/BK
TB3-94
9-O/BK
414526
DATA[13].07
L2-0 9
L1-0 10
A:11:O.08
11
TB3-136
414558
DATA[13].08
A:11:O.09
12
TB3-137
N404100
TB3-125
414560
DATA[13].09
A:11:O.10
13
414558
11-BR/BK
SPARE
OUTPUT
TB3-138
414562
DATA[13].10
N404100
TB3-78
N404100
TB3-79
N404100
TB3-95
414532
TB3-96
TB3-80
AERATION
SOLENOID
64
POCKET PURGE SOLENOID
66
BEARING PURGE SOLENOID
68
SPARE
OUTPUT
70
SPARE
OUTPUT
72
A:11:O.11
14
DATA[13].11
A:11:O.12
15
N404100
TB3-139
A:11:O.13
16
DATA[13].13
A:11:O.14
17
DATA[13].14
A:11:O.15
18
DATA[13].15
TB3-126
SPARE
OUTPUT
TB3-140
414566
414564
N404100
7-R/BK
2-R
TB3-126
414566
TB3-141
8-BL/BK
TB3-142
9-O/BK
414568
N404100
N404100
TB3-127
AERATION
SOLENOID
414568
414570
N404100
TB3-143
TB3-128
414572
SPARE
OUTPUT
SPARE
OUTPUT
TB3-144
L2-1 19
74
L1-1 20
414500
414564
DATA[13].12
L2-1 19
34
UNIT 2 DSI SILO
TRUCK UNLOAD
ALARM BEACON
REF.
4143-67
414528
414530
DATA[12].14
32
TB3-92
2-R
414528
DATA[12].13
30
N404100
414526
DATA[12].12
28
414524
7-R/BK
UNIT 2 T.U. BLOWER
RUNNING
PILOT LIGHT
UNIT 2 DSI SILO
TRUCK UNLOAD
ALARM HORN
414556
10-Y/BK
REF.
4143-27
A:10:O.11
14
UNIT 2 DSI SILO
MID LEVEL
PILOT LIGHT
UNIT 2 DSI SILO
LOW LEVEL
PILOT LIGHT
414552
TB3-134
DATA[13].06
N404100
7-R/BK
REF.
4176-53
X SP
414516
DATA[12].07
L2-0 9
L1-0 10
18
N404100
TB3-75
N404100
L1-1 20
N404100
414540
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4145
WIRING LEGEND
SPARE SLOT
RACK A, SLOT 12
- DENOTES PRE-WIRED
00
40
02
42
04
44
06
46
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
I/O WIRING DIAGRAM, RACK A SLOT 12
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4146
413610
413603
02
40
2A
TB4-5
ALLEN-BRADLEY #1756-ENT2
ETHERNET MODULE
RACK B, SLOT 0
00
CB-414740
WIRING LEGEND
- DENOTES PRE-WIRED
1756-IF6I
42
ALLEN-BRADLEY #1756-IF6I
ANALOG INPUT MODULE
RACK B, SLOT 1
1 (IN-0/V)
414740
414740
CH0DATA
TB5-1
04
REF.
4178-00
44
1-BK
414744
414744
02CBA4500
1-W
X SP
B:01:I.CH0
3 (IN-O/I)
TB5-4
413603
UNIT 2 DSI SILO
CONTINUOUS LEVEL
TRANSMITTER 1
(RET-0) 5
SHLD
06
46
2 (IN-1/V)
1-SH
414740
TB5-6
414740
CH1DATA
1756-EN2T
TB5-1
2-BK
ETHERNET/IP
08
TB5-5
SHLD
414748
48
2-W
10/100 BASE T
414748
B:01:I.CH1
4 (IN-1/I)
TB5-7
413603
UNIT 2 DSI SILO
CONTINUOUS LEVEL
TRANSMITTER 2
(RET-1) 6
10
50
SHLD
TB5-8
SHLD
2-SH
TB5-6
7 (IN-2/V)
414740
414740
CH2DATA
TB5-2
LINK
NET
3-BK
OK
12
414752
52
3-W
414752
B:01:I.CH2
9 (IN-2/I)
TB5-9
413603
UNIT 2 DSI SILO
DUST COLL. DIFFERENTIAL
PRESSURE TRANSMITTER
(RET-2) 11
14
54
SHLD
TB5-10
SHLD
3-SH
TB5-11
8 (IN-3/V)
414740
414740
CH3DATA
TB5-2
16
USB
PORT
REF.
4301-28
56
1-BK
414756
414756
02CBA4501
1-W
X SP
B:01:I.CH3
10 (IN-3/I)
TB5-12
413603
UNIT 2 T.U. BLOWER
PRESSURE
TRANSMITTER
(RET-3) 12
18
58
20
SHLD
TB5-13
SHLD
1-SH
TB5-11
NOT USED
13
60
15 (IN-4V)
414740
414740
CH4DATA
TB5-3
22
24
26
REF.
4301-31
62
RJ45 CABLE
CONNECTOR
LOCATED ON
UNDERSIDE OF
MODULE
1-BK
414762
414762
02CBA4502
1-W
X SP
B:01:I.CH4
17 (IN-4/I)
TB5-14
413603
UNIT 2 T.U. BLOWER
TEMPERATURE
TRANSMITTER
(RET-4) 19
64
SHLD
TB5-15
SHLD
1-SH
TB5-16
NOT USED
14
66
16 (IN-5/V)
414740
414740
CH5DATA
TB5-3
28
REF.
4302-19
68
1-BK
414768
414768
02CBA4503
1-W
X SP
B:01:I.CH5
18 (IN-5/I)
TB5-17
413603
UNIT 2 T.U. BLOWER
HEAT EXCHANGER
TEMPERATURE TRANSMITTER
(RET-5) 20
SHLD
30
70
32
72
34
74
1-SH
TB5-18
SHLD
TB5-16
04603
414740
I/O WIRING DIAGRAM, RACK B SLOTS 0 & 1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4147
413610
413603
413610
413603
02
ANALOG INPUT MODULE
RACK B, SLOT 2
40
2A
TB4-7
1756-IF6I
CB-414840
2A
TB4-6
00
CB-414800
WIRING LEGEND
- DENOTES PRE-WIRED
1756-IF6I
42
1 (IN-0/V)
414800
414840
CH0DATA
REF.
4115-12
CH0DATA
TB5-37
414804
414804
02CBA4504
B:02:I.CH0
3 (IN-O/I)
1-W
X SP
TB5-22
414805
414805
BLOWER
OUTPUT FREQUENCY
REF.
4125-12
44
414844
414844
02CBA4510
B:03:I.CH0
3 (IN-O/I)
1-W
X SP
TB5-40
414845
414845
(RET-0) 5
1-BK
SHLD
06
SHLD
46
TB5-41
SHLD
2 (IN-1/V)
1-SH
TB5-24
TB5-42
CH1DATA
414808
08
414808
B:02:I.CH1
4 (IN-1/I)
3-W
TB5-25
414809
414809
CH1DATA
OUTPUT FREQUENCY
414848
48
414848
B:03:I.CH1
4 (IN-1/I)
3-W
TB5-43
414849
414849
(RET-1) 6
3-BK
10
SHLD
TB5-26
SHLD
3-SH
TB5-24
50
414800
SHLD
TB5-44
SHLD
3-SH
TB5-42
7 (IN-2/V)
414840
CH2DATA
CH2DATA
TB5-20
TB5-38
414812
12
414812
B:02:I.CH2
9 (IN-2/I)
5-W
TB5-27
414813
414813
OUTPUT FREQUENCY
414852
52
414852
B:03:I.CH2
9 (IN-2/I)
5-W
TB5-45
414853
414853
(RET-2) 11
5-BK
REF.
4150-54
14
414800
SHLD
TB5-28
SHLD
5-SH
TB5-29
REF.
4151-14
54
8 (IN-3/V)
414840
SHLD
TB5-46
SHLD
5-SH
TB5-47
8 (IN-3/V)
414840
CH3DATA
REF.
4301-05
CH3DATA
1-BK
TB5-38
414816
414816
02CBA4507
1-W
X SP
B:02:I.CH3
10 (IN-3/I)
TB5-30
413603
BLOWER
REF.
4301-16
56
1-BK
414856
414856
02CBA4513
1-W
X SP
B:03:I.CH3
10 (IN-3/I)
TB5-48
413603
(RET-3) 12
18
SHLD
TB5-31
SHLD
1-SH
TB5-29
20
58
SHLD
TB5-49
SHLD
1-SH
TB5-47
15 (IN-4V)
414840
414840
CH4DATA
REF.
4301-08
CH4DATA
1-BK
TB5-39
414822
414822
02CBA4508
1-W
X SP
B:02:I.CH4
17 (IN-4/I)
TB5-32
413603
NOT USED
13
60
414800
TB5-21
BLOWER
REF.
4301-19
62
1-BK
414862
414862
02CBA4514
1-W
X SP
B:03:I.CH4
17 (IN-4/I)
TB5-50
413603
(RET-4) 19
24
SHLD
TB5-33
SHLD
1-SH
TB5-34
26
64
SHLD
TB5-51
SHLD
1-SH
TB5-52
16 (IN-5/V)
414840
414840
CH5DATA
REF.
4302-04
CH5DATA
1-BK
TB5-39
414828
414828
02CBA4509
1-W
X SP
B:02:I.CH5
18 (IN-5/I)
TB5-35
413603
NOT USED
14
66
414800
TB5-21
REF.
4302-11
68
1-BK
414868
414868
02CBA4515
1-W
X SP
B:03:I.CH5
18 (IN-5/I)
TB5-53
413603
(RET-5) 20
SHLD
30
1-SH
(RET-5) 20
TB5-36
SHLD
SHLD
70
1-SH
TB5-34
32
72
34
74
414800
BLOWER
(RET-4) 19
NOT USED
14
16 (IN-5/V)
414800
BLOWER
(RET-3) 12
NOT USED
13
15 (IN-4V)
414800
OUTPUT FREQUENCY
(RET-2) 11
5-BK
414800
TB5-20
28
OUTPUT FREQUENCY
(RET-1) 6
3-BK
7 (IN-2/V)
22
BLOWER
OUTPUT FREQUENCY
(RET-0) 5
1-BK
TB5-23
SHLD
2 (IN-1/V)
1-SH
16
1 (IN-0/V)
TB5-19
04
ANALOG INPUT MODULE
RACK B, SLOT 3
413603
TB5-54
SHLD
TB5-52
413603
414840
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4148
413610
413603
413610
413603
02
ANALOG INPUT MODULE
RACK B, SLOT 4
40
2A
TB4-9
1756-IF6I
CB-414940
2A
TB4-8
00
CB-414900
WIRING LEGEND
- DENOTES PRE-WIRED
1756-IF6I
42
1 (IN-0/V)
414900
414940
CH0DATA
CH0DATA
TB5-73
414904
04
B:04:I.CH0
3 (IN-O/I)
TB5-58
414905
CHANNEL 0
SPARE ANALOG
INPUT
414944
44
B:05:I.CH0
3 (IN-O/I)
TB5-76
414945
(RET-0) 5
06
TB5-77
SHLD
46
2 (IN-1/V)
2 (IN-1/V)
TB5-60
414900
TB5-78
414900
CH1DATA
TB5-55
REF.
4300-14
CH1DATA
1-BK
414908
414908
02CBA4517
1-W
X SP
B:04:I.CH1
4 (IN-1/I)
TB5-61
413603
UNIT 2 DSI
DRY AIR SURGE TANK 1
414948
48
B:05:I.CH1
4 (IN-1/I)
TB5-79
414949
(RET-1) 6
SHLD
TB5-80
SHLD
50
7 (IN-2/V)
7 (IN-2/V)
TB5-60
TB5-78
414900
414940
CH2DATA
CH2DATA
TB5-56
TB5-74
414912
REF.
4178-12
414912
B:04:I.CH2
9 (IN-2/I)
1-W
X SP
TB5-63
414913
414913
PRESSURE
TRANSMITTER
52
REF.
414952
4149-14
2-W
414952
B:05:I.CH2
9 (IN-2/I)
TB5-81
414953
414953
(RET-2) 11
1-BK
REF.
4149-52
14
SHLD
TB5-64
SHLD
1-SH
TB5-65
54
8 (IN-3/V)
414916
414916
02CBA4518
1-W
X SP
414917
B:04:I.CH3
10 (IN-3/I)
TB5-66
414917
TB5-82
SHLD
2-SH
TB5-83
8 (IN-3/V)
CH3DATA
WEIGH SCALE
GROSS WEIGHT
REF.
4149-18
56
414956
2-W
414957
414956
B:05:I.CH3
10 (IN-3/I)
TB5-84
414957
(RET-3) 12
1-BK
REF.
4149-56
18
SHLD
TB5-67
SHLD
1-SH
TB5-65
20
58
SHLD
TB5-85
SHLD
2-SH
TB5-83
NOT USED
13
60
15 (IN-4V)
15 (IN-4V)
414940
CH4DATA
CH4DATA
TB5-57
TB5-75
414922
22
B:04:I.CH4
17 (IN-4/I)
TB5-68
414923
CHANNEL 4
SPARE ANALOG
INPUT
414962
62
B:05:I.CH4
17 (IN-4/I)
TB5-86
414963
(RET-4) 19
TB5-69
SHLD
24
26
64
NOT USED
14
TB5-88
66
16 (IN-5/V)
414900
CHANNEL 4
SPARE ANALOG
INPUT
(RET-4) 19
TB5-87
SHLD
NOT USED
14
TB5-70
16 (IN-5/V)
414900
CH5DATA
TB5-57
REF.
4302-30
CH5DATA
1-BK
414928
414928
02CBA4519
1-W
X SP
B:04:I.CH5
18 (IN-5/I)
TB5-71
413603
EVAPORATOR
DIFF. PRESSURE TRANSMITTER
414968
68
B:05:I.CH5
18 (IN-5/I)
TB5-89
414969
(RET-5) 20
SHLD
1-SH
CHANNEL 5
SPARE ANALOG
INPUT
(RET-5) 20
TB5-72
SHLD
TB5-90
SHLD
70
TB5-70
TB5-88
32
72
34
74
414900
WEIGH SCALE
GROSS WEIGHT
(RET-3) 12
2-BK
NOT USED
13
414900
30
PRESSURE
TRANSMITTER
(RET-2) 11
2-BK
SHLD
CH3DATA
REF.
4175-28
28
CHANNEL 1
SPARE ANALOG
INPUT
(RET-1) 6
TB5-62
SHLD
10
16
CHANNEL 0
SPARE ANALOG
INPUT
(RET-0) 5
TB5-59
SHLD
12
1 (IN-0/V)
TB5-55
08
ANALOG INPUT MODULE
RACK B, SLOT 5
413603
413603
414940
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4149
413610
413603
413610
413603
ANALOG INPUT MODULE
RACK B, SLOT 6
40
2A
TB4-11
1756-IF6I
CB-415040
2A
TB4-10
00
CB-415000
WIRING LEGEND
- DENOTES PRE-WIRED
1756-OF6CI
B:07:O.CH0
02
42
1 (IN-0/V)
415042
415042
2-W
TB5-112
BLOWER
SPEED COMMAND
REF.
4148-14
(OUT-0) 1
CH0DATA
ALLEN-BRADLEY #1756-OF6CI
ANALOG OUTPUT MODULE
RACK B, SLOT 7
415000
(ALT-0) 3
CH0DATA
TB5-91
415004
04
B:06:I.CH0
3 (IN-O/I)
TB5-94
415005
CHANNEL 0
SPARE ANALOG
INPUT
415044
44
415044
413603
(RTN-0) 5
2-BK
TB5-113
SHLD
TB5-109
SHLD
(RET-0) 5
TB5-95
SHLD
06
2-SH
TB5-114
46
2 (IN-1/V)
TB5-96
CH1DATA
415008
08
B:06:I.CH1
4 (IN-1/I)
TB5-97
415009
CHANNEL 1
SPARE ANALOG
INPUT
B:07:O.CH1
48
CH1DATA
SPEED COMMAND
415048
4-W
TB5-115
(ALT-1) 4
(RET-1) 6
TB5-98
SHLD
10
415048
(OUT-1) 2
415050
50
7 (IN-2/V)
415050
(RTN-1) 6
TB5-96
4-BK
TB5-116
SHLD
415000
SHLD
CH2DATA
TB5-92
415012
12
B:06:I.CH2
9 (IN-2/I)
TB5-99
415013
CHANNEL 2
SPARE ANALOG
INPUT
4-SH
TB5-114
52
(RET-2) 11
TB5-100
SHLD
14
B:07:O.CH2
54
8 (IN-3/V)
TB5-101
415016
CH2DATA
B:06:I.CH3
10 (IN-3/I)
TB5-102
415017
SPEED COMMAND
415054
TB5-117
6-W
(ALT-2) 9
CH3DATA
16
415054
(OUT-2) 7
CHANNEL 3
SPARE ANALOG
INPUT
415056
56
415056
413603
(RTN-2) 11
TB5-118
SHLD
6-BK
TB5-110
SHLD
(RET-3) 12
TB5-103
SHLD
18
TB5-119
NOT USED
13
6-SH
58
TB5-101
B:07:O.CH3
20
60
15 (IN-4V)
415060
415060
(OUT-3) 8
CH3DATA
02CBA4529
TB5-120
1-W
UNIT 2 DSI SILO
SPACE AVAILABLE
DISPLAY
REF.
4165-08
X SP
415000
(ALT-3) 10
CH4DATA
TB5-93
415022
22
B:06:I.CH4
17 (IN-4/I)
TB5-104
415023
CHANNEL 4
SPARE ANALOG
INPUT
415062
62
415062
(RTN-3) 12
TB5-121 1-BK
SHLD
SHLD
(RET-4) 19
TB5-105
SHLD
24
(N/A) 13
NOT USED
14
TB5-106
66
16 (IN-5/V)
CH4DATA
415028
B:06:I.CH5
18 (IN-5/I)
TB5-107
415029
CHANNEL 4
SPARE ANALOG
OUTPUT
415066
(OUT-4) 15
TB5-122
(ALT-4) 17
CH5DATA
28
1-SH
14 (N/A)
B:07:O.CH4
26
TB5-119
64
CHANNEL 5
SPARE ANALOG
INPUT
415068
68
413603
(RTN-4) 19
TB5-123
SHLD
TB5-111
(RET-5) 20
TB5-108
SHLD
TB5-124
30
70
TB5-106
B:07:O.CH5
32
72
CHANNEL 5
SPARE ANALOG
OUTPUT
415072
(OUT-5) 16
CH5DATA
TB5-125
(ALT-5) 18
415074
34
74
(RTN-5) 20
TB5-126
SHLD
415000
413603
415040
413603
TB5-124
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4150
413610
413603
2A
TB4-12
00
CB-415100
WIRING LEGEND
SPARE SLOT
RACK B, SLOT 9
1756-OF6CI
B:08:O.CH0
02
415102
415102
(OUT-0) 1
CH0DATA
2-W
TB5-130
REF.
4148-54
- DENOTES PRE-WIRED
ALLEN-BRADLEY #1756-OF6CI
ANALOG OUTPUT MODULE
RACK B, SLOT 8
40
BLOWER
SPEED COMMAND
42
(ALT-0) 3
415104
04
415104
413603
44
(RTN-0) 5
TB5-131 2-BK
SHLD
SHLD
TB5-132
TB5-127
2-SH
06
46
B:08:O.CH1
08
415108
SPEED COMMAND
415108
(OUT-1) 2
CH1DATA
TB5-133
4-W
48
(ALT-1) 4
415110
10
415110
50
(RTN-1) 6
TB5-134 4BK
SHLD
SHLD
TB5-132
4-SH
12
52
B:08:O.CH2
14
415114
SPEED COMMAND
415114
(OUT-2) 7
CH2DATA
TB5-135
6-W
54
(ALT-2) 9
415116
16
415116
413603
56
(RTN-2) 11
TB5-136 6-BK
SHLD
SHLD
TB5-137
TB5-128
6-SH
18
58
B:08:O.CH3
20
CHANNEL 3
SPARE ANALOG
OUTPUT
415120
(OUT-3) 8
CH3DATA
TB5-138
60
(ALT-3) 10
415122
22
62
(RTN-3) 12
TB5-139
SHLD
TB5-137
(N/A) 13
24
64
14 (N/A)
B:08:O.CH4
26
CHANNEL 4
SPARE ANALOG
OUTPUT
415126
(OUT-4) 15
CH4DATA
TB5-140
66
(ALT-4) 17
415128
28
413603
68
(RTN-4) 19
TB5-141
SHLD
TB5-129
TB5-142
30
70
B:08:O.CH5
32
415132
(OUT-5) 16
CH5DATA
TB5-143
CHANNEL 5
SPARE ANALOG
OUTPUT
72
(ALT-5) 18
415134
34
74
(RTN-5) 20
TB5-144
SHLD
415100
TB5-142
413603
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4151
8"
9
4"
20"
C DOOR
L
1
3"
A-CP4160
1•"
1•"
3"
SPACE
AVAILABLE
3
PRECISION DIGITAL +
30
4
RESET
MAX
10
11
12
13
ACK
4"
MENU
10"
3
EMERGENCY
ALARM
3
HIGH LEVEL
SILENCE
5
3
8
B
1"
3
HIGH
FILL LINE
BLOWER
LEVEL
CONNECTED
RUNNING
A
R
WARNING!
POWER FED FROM
MULTPLE SOURCES
6
R
14
3"
3
MID
DUST COLL.
BLOWER
LEVEL
ON
START
A
R
B
LOW
DUST COLL.
BLOWER
3
3"
C DOOR
L
20"
2"
R
3
5
LEVEL
HAND
AUTO
R
8
STOP
B
3
7
ENCLOSURE:
NEMA 4X, 304SS
HOFFMAN A20H2008SSLP
20.00"H x 20.00"W x 8.00"D
BACKPANEL:
HOFFMAN A20P20
17.00"H x 17.00"W
A-CP4160 TRUCK UNLOAD PANEL
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65380
2007
DRAWING NO.
9190A-7-4160
17"
12‡ "
8† "
7„ "
4‚ "
0"
2
0"
1" x 4" WIREWAY
24
1•"
TB2
23
19
18
CB
1" x 4" W I
REW AY
TB1
25
1" x 4" W I
REW AY
26
TB2 (6) 1492-J4-B
1" x 4" WIREWAY
28
17
CB
16
CB
(30) 1492-J4
6"
22
1" x 4" WIREWAY
1" x 4" W I
REW AY
21
1" x 4" W I
REW AY
20
TB1 (2) 1492-J6,(1) 1492-JG6 &
25
CLEAR AREA
27
15
ELECTRIC HEATER
29
1" x 4" WIREWAY
17"
ENCLOSURE:
NEMA 4X, 304SS
20.00"H x 20.00"W x 8.00"D
BACKPANEL:
HOFFMAN A20P20
17.00"H x 17.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/4"=1"
c
CATALOG NO.
65380
2007
DRAWING NO.
9190A-7-4161
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 20" X 20" X 8" 304SS
HOFFMAN
MANUFACTURER
A-20H2008SSLP
PART No.
2
1
BACK PANEL, 17.00" X 17.00"
HOFFMAN
A20P20
3
14
PER PRINT/LIST
LEGEND
4
1
INDICATOR, ANALOG PROCESS, 4-20MA INPUT 85-265 VAC POWER, LARGE DISPLAY
TRIDENT
PD765-6X0-00
5
5
PILOT LIGHT, RED, 12-130V, AC/DC, LED NEMA 4X
ALLEN-BRADLEY
800H-QRH2R
6
2
PILOT LIGHT, AMBER, 12-130V, AC/DC, LED, NEMA 4X
ALLEN-BRADLEY
800H-QRH2A
7
1
SELECTOR SWITCH, 2 POS, 1 NO, 1 NC, NEMA 4X
ALLEN-BRADLEY
800H-HR2A
8
3
PUSH BUTTON, NEMA 4X, FLUSH HEAD, BLACK, 1NC, 1 NO
ALLEN-BRADLEY
800H-AR2A
9
1
BEACON, ADAPTA BEACON, RED, STROBE 120 VAC, 60/60HZ, NEMA 4X, 3 JOULES
EDWARDS
105STR-N5
10
1
PIPE MOUNT ATTACHMENT, 3/4" NPT, FOR 105 SERIES ADAPTA BEACON
EDWARDS
105PM
11
1
CONNECTOR, CONDUIT, 3/4", 316SS
MYERS
SSTG-2
12
2
NIPPLE, 3/4" X CLOSE, 316 SS
MYERS
-
13
1
ELBOW, CONDUIT, 3/4"
CROUSE & HINDS
LB27
14
1
HORN, 120 VAC, 103DB, NEMA 4X, PANEL MOUNTING, ADJUSTABLE VOLUME
EDWARDS
870P-N5
15
1
HEATER, 115 VAC, CABINET, 0.98A, 100W
HOFFMAN
DAH1001A
16
2
ALLEN-BRADLEY
1489-M1C020
17
1
ALLEN-BRADLEY
1489-M1C100
18
2
ALLEN-BRADLEY
1492-J6
19
1
ALLEN-BRADLEY
1492-JG6
20
30
TERMINAL BLOCK, 22-10 AWG, 600V, 35A
ALLEN-BRADLEY
1492-J4
21
1
ALLEN-BRADLEY
1492-CJJ6-10
22
1
ALLEN-BRADLEY
1492-CJJ6-4
23
6
ALLEN-BRADLEY
1492-J4-B
24
1
ALLEN-BRADLEY
1492-EBJ3-B
25
4
ALLEN-BRADLEY
1492-EBJ3
26
4
ALLEN-BRADLEY
1492-EAJ35
27
1
GROUND BAR 7 POINT
SQUARE D
PK7GTA
28
90"
PHOENIX CONTACT
CD-HF 30X100 3240347
29
19"
DIN RAIL
ALLEN-BRADLEY
199-DR1
30
1
CONDUIT BODY COVER,ƒ"
CROUSE & HINDS
270G
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65380
2007
DRAWING NO.
9190A-7-4162
TB1
TB2
413514
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-CP4160
.
ƒ" x 4•"
•"
WHITE
BLACK
415060
1
415062
2
SHLD
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
1
SPACE
AVAILABLE
1" x 3"
‚"
WHITE
BLACK
4
1
EMERGENCY
HIGH LEVEL
2‚" x 2‚"
WHITE
BLACK
5
6
413514
TB1-4
10
AMP
TB1-5
2
AMP
TB1-6
2
AMP
416502
4
416502
416504
5
416506
5
1
HIGH
LEVEL
2‚" x 2‚"
‰"
WHITE
BLACK
6
1
MID
LEVEL
2‚" x 2‚"
‰"
WHITE
BLACK
7
7
1
LOW
LEVEL
2‚" x 2‚"
‰"
WHITE
BLACK
8
8
1
FILL LINE
CONNECTED
2‚" x 2‚"
‰"
WHITE
BLACK
9
9
1
DUST COLL.
ON
2‚" x 2‚"
‰"
WHITE
BLACK
10
10
1
DUST COLL.
2‚" x 2‚"
‰"
WHITE
BLACK
AUTO
3
4
3
1
3
HAND
2
GND
2
‰"
CB & FUSE CHART
1
N404100
6
N404100
JOB #9190A
11
120/1/60
416502
11
1
BLOWER
RUNNING
2‚" x 2‚"
‰"
WHITE
BLACK
12
12
1
BLOWER
START
2‚" x 2‚"
‰"
WHITE
BLACK
13
13
1
BLOWER
STOP
2‚" x 2‚"
‰"
WHITE
BLACK
14
14
1
ALARM
SILENCE
2‚" x 2‚"
‰"
WHITE
BLACK
15
16
414340
17
18
1
414342
A-CP4160
19
HOLES IN ENCLOSURE
20
MUST BE FILLED WITH
21
NEMA TYPE 4X DEVICES
414344
414346
414348
22
414350
2
23
3
WARNING!
POWER FED FROM
MULTPLE SOURCES
414352
24
SPACE
AVAILABLE
N404100
25
26
414542
27
414544
28
COPPER WIRE WITH
29
60 DEG C INSULATION
414546
414548
4
5
EMERGENCY
6
HIGH
HIGH LEVEL
LEVEL
30
7
MID
414550
LOW
LEVEL
LEVEL
31
414552
32
414554
33
414556
34
TERMINAL BLOCK
414558
35
TIGHTENING TORQUE
36
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
8
9
10
FILL LINE
DUST COLL.
CONNECTED
ON
11
DUST COLL.
HAND
AUTO
BLOWER
RUNNING
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
12
13
TB1
14
BLOWER
BLOWER
ALARM
START
STOP
SILENCE
TB2
2‚"
0„ "
1Œ "
2‚ "
0‰"
1‰"
1„"
30.5mm
1
26AUG15
0
01JUN15
PANEL AS BUILT
LEGEND DETAIL
REV
DATE
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65380
2007
DRAWING NO.
9190A-7-4163
WIRING LEGEND
- DENOTES PRE-WIRED
GND
REF.
4135-15
00
40
02CBD4151
3-BL
TB1-3
0 SP
REF.
4143-41
X SP
CB-416502
416502
02
413514
10A
TB1-4
413514
N404100
1-BK
TB1-1
02CBD4249
N404100
2-R
HAND
414340
414340
42
TB1-2
1-BK
AUTO
414342
xo
TB1-17
414342
2-R
TB1-19
UNIT 2 DSI SILO
DUST COLLECTOR "HAND"
SELECTOR SWITCH
CB-416504
416502
04
416504
2A
TB1-5
N404100
H
HEATER
N
TB1-7
120VAC POWER TO
ENCLOSURE
HEATER
414344
44
414344
ox
4-O
TB1-20
UNIT 2 DSI SILO
DUST COLLECTOR "AUTO"
SELECTOR SWITCH
CB-416504
416502
06
416504
UNIT 2 DSI SILO
SPACE AVAILABLE
N404100
2+
2A
TB1-6
POWER
1-
TB1-7
414346
414346
46
DISPLAY
5-Y
TB1-21
UNIT 2 DSI SILO
TRUCK UNLOAD ALARM SILENCE
PUSH BUTTON
PRECISION
DIGITAL
DISPLAY
REF.
4150-60
415060
415060
02CBA4529
2
1-BK
X SP
415062
415062
5
1-W
1-SH
COM
414348
414348
48
TB1-22
6-BR
TB1-23
7-R/BK
UNIT 2 T.U. BLOWER
START
PUSH BUTTON
TB2-2
SHLD
10
MA+
TB2-1
SI
GNAL
CONNECTOR
08
SHLD
414350
414350
50
TB2-3
12
52
TB1-18
414340
414352
1-BK
2-R
414352
TB1-24
8-R/BK
UNIT 2 T.U. BLOWER
STOP
PUSH BUTTON
UNIT 2 DSI SILO
LIMIT SWITCH
REF.
4303-23
02CBD4300
X SP
14
54
16
56
REF.
4145-41
02CBD4281
X SP
414542
18
58
414542
TB1-27
414544
20
60
4-O
62
5-Y
64
6-BR
66
7-R/BK
68
8-R/BK
70
9-O/BK
72
10-Y/BK
74
416502
A
UNIT 2 DSI SILO
HIGH LEVEL
PILOT LIGHT
A
UNIT 2 DSI SILO
MID LEVEL
PILOT LIGHT
R
UNIT 2 DSI SILO
LOW LEVEL
PILOT LIGHT
R
UNIT 2 T.U. BLOWER
RUNNING
PILOT LIGHT
414550
TB1-31
414552
TB1-32
414554
TB1-33
414556
TB1-25
UNIT 2 DSI SILO
TRUCK UNLOAD
ALARM HORN
TB1-26
UNIT 2 DSI SILO
TRUCK UNLOAD
ALARM BEACON
N404100
TB1-34
414558
34
UNIT 2 DSI SILO
EMERGENCY HIGH LEVEL
PILOT LIGHT
TB1-30
414556
32
R
414548
414554
30
UNIT 2 DSI SILO
PILOT LIGHT
TB1-29
414552
28
414558
N404100
R
11-BR/BK
UNIT 2 DSI SILO
DUST COLLECTOR ON
PILOT LIGHT
R
414546
414550
26
TB1-25
2-R
TB1-28
414548
24
N404100
414544
414546
22
N404100
R
1-BK
TB1-35
N404100
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4165
24"
10"
C DOOR
L
1
5"
5"
A-CP4170
3
3
SCALE 1
4
10"
4
SCALE 2
C DOOR
L
36"
3
WARNING!
POWER FED FROM
MULTPLE SOURCES
ENCLOSURE:
NEMA 12
HOFFMAN A362410LP
36.00"H x 24.00"W x 10.00"D
BACKPANEL:
HOFFMAN A36P24
33.00"H x 21.00"W
A-CP4170 SILO MARSHALLING CABINET
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65381
2007
DRAWING NO.
9190A-7-4170
21"
15‡ "
10† "
8„ "
5‚ "
0"
2
0"
17
17
2" x 4" WIREWAY
CB
CB
15
N L
SUPPLY
SOLA
2.5-24-100P
POW ER
+ +
5
SDN
- -
11
TB3
7
16
6
12
20
19
2" x 4" W I
REW AY
2" x 4" W I
REW AY
18
2" x 4" W I
REW AY
6
CB
2" x 4" W I
REW AY
CB
10
CB
8
TB3 (38) 1492-J4-B
TB1
9
TB1 (2) 1492-J6,(1) 1492-JG6 &
(10) 1492-J4
15
TB2
13
14
TB2 (50) 1492-J4
11
CELL 1
JP1
PT2
+
+
-
EXC
EXC
EXC
EXP
+
+
+
-
EXC
EXC
SEN
SIG
EXC
SEN
SHLD
SEN
SIG
SIG
SIG
SEN
EXC
SHLD
EXC
IND
+
+
+
-
SIG
SIG
SHLD
+
+
SHLD
SIG
SIG
+
+
SIG
SIG
SIG
SIG
SHLD
SHLD
EXC
EXC
EXC
EXC
PT4
CELL 4
PT3
JP4
CELL 1
JP1
CELL 2
JP2
PT2
+
+
-
EXC
EXC
EXC
EXP
+
+
+
-
EXC
SIG
SEN
SIG
EXC
SHLD
SEN
SHLD
SIG
SIG
SIG
EXC
IND
+
+
+
-
EXC
SIG
SEN
SIG
EXC
SHLD
SEN
SHLD
SIG
+
+
SIG
SIG
SIG
SIG
SHLD
SHLD
EXC
EXC
EXC
CELL 4
CELL 3
JP3
PT1
+
+
-
+
+
SUPPLIED WITH
KIT ON WEIGH
HOPPER ASSEMBLY
CELL 2
JP2
PT1
+
+
-
EXC
PT4
PT3
JP4
JP3
CELL 3
2" x 4" WIREWAY
33"
ENCLOSURE:
NEMA 12
HOFFMAN A362410LP
36.00"H x 24.00"W x 10.00"D
BACKPANEL:
HOFFMAN A36P24
33.00"H x 21.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1/2"=1"
c
CATALOG NO.
65381
2007
DRAWING NO.
9190A-7-4171
ITEM
QTY.
DESCRIPTION
1
1
HOFFMAN
MANUFACTURER
A-362410LP
PART No.
2
1
BACK PANEL, 33.00" X 21.00"
HOFFMAN
A-36P24
3
4
PER PRINT/LIST
LEGEND
4
2
WEIGH SCALE CONTROLLER, PANEL MOUNT, 24VDC, ANALOG & ETHERNET
HARDY INSTRUMENTS
HI 6510-WP-10-EIP
5
1
POWER SUPPLY, 2.5 AMP, 24VDC, DIN MOUNT
SOLA
SDN 2.5-24-100P
6
3
ALLEN-BRADLEY
1489-M1C010
7
1
ALLEN-BRADLEY
1489-M1C030
8
1
ALLEN-BRADLEY
1489-M1C100
9
2
ALLEN-BRADLEY
1492-J6
10
1
ALLEN-BRADLEY
1492-JG6
11
60
TERMINAL BLOCK, 22-10 AWG, 600V, 35AMP
ALLEN-BRADLEY
1492-J4
12
38
ALLEN-BRADLEY
1492-J4-B
13
1
ALLEN-BRADLEY
1492-CJJ6-10
14
1
ALLEN-BRADLEY
1492-CJJ6-4
15
4
ALLEN-BRADLEY
1492-EBJ3
16
2
ALLEN-BRADLEY
1492-EBJ3-B
17
7
ALLEN-BRADLEY
1492-EAJ35
18
2
GROUND BAR 7 POINT
SQUARE D
PK7GTA
19
180" WIRE DUCT, 2" WD, 4" DEEP, GREY, HALOGEN FREE, W/COVER
PHOENIX CONTACT
CD-HF 60X100 3240355
20
55"
ALLEN-BRADLEY
199-DR1
DIN RAIL
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65381
2007
DRAWING NO.
9190A-7-4172
TB1
TB2
413516
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-CP4170
.
ƒ" x 4•"
•"
WHITE
BLACK
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
SCALE 1
.
1" x 3"
‚"
WHITE
BLACK
4
1
SCALE 2
.
1" x 3"
WHITE
BLACK
‚"
TB3
414300
417512
1
N404100
1
1
2
2
N404100
GND
414314
417513
3
413516
3
417502
4
417504
5
9
10
AMP
8
TB3-2
1
AMP
SHLD
10
10
414356
414740
11
11
11
414358
414744
12
13
12
SHLD
13
414740
14
414364
15
14
120/1/60
15
414748
15
414516
16
JOB #9190A
13
414362
14
SHLD
16
16
N404100
414740
17
17
414518
414752
18
18
414520
SHLD
19
19
414522
414912
20
20
414300
414913
21
SCALE 2
1
9
414354
414360
SCALE 1
TB3-1
414957
9
12
4
AMP
7
414956
8
414340
3
1
SHLD
7
414508
WARNING!
POWER FED FROM
MULTPLE SOURCES
AMP
TB1-6
6
414318
8
2
AMP
3
414917
6
7
417502
10
TB1-5
5
417510
6
A-CP4170
TB1-4
414916
5
N404100
3
4
414316
4
417502
CB & FUSE CHART
417570
2
1
417530
21
414328
HOLES IN ENCLOSURE
SHLD
22
22
414330
MUST BE FILLED WITH
414952
23
23
414332
414953
24
24
414524
SHLD
25
25
N404100
26
26
27
27
28
28
414526
414528
414340
29
29
30
30
31
31
414368
COPPER WIRE WITH
414370
414372
32
60 DEG C INSULATION
32
414564
33
33
34
34
35
35
36
36
N404100
414566
414568
37
TERMINAL BLOCK
38
TIGHTENING TORQUE
39
1492-J4 - 9.0 LB-IN
40
41
1492-J6 - 14.2 LB-IN
42
1492-H... - 7.1 LB-IN
43
44
45
46
U
L
47
R
Underwriters
Laboratories Inc.
R
48
LISTED
49
50
No. AA-______
TB1
TB2
TB3
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65381
2007
DRAWING NO.
9190A-7-4173
417502
N404100
WIRING LEGEND
- DENOTES PRE-WIRED
GND
REF.
4135-17
00
40
02CBD4152
3-BL
TB1-3
0 SP
CB-417502
417502
02
413516
10A
TB1-4
413516
N404100
1-BK
2-R
417504
N404100
1-BK
2-R
TB1-1
N404100
42
TB1-2
CB-417504
417502
04
3A
TB1-5
N404100
TB1-7
GND
120VAC POWER TO
UNIT 2 DSI SILO
DUST COLLECTOR
44
REF.
4185-08
02CBD4301
3-BL
X SP
REF.
4176-12
06
46
08
48
CB-417510
417502
10
417510
N404100
50
1A
TB1-6
417502
L N G
N404100
SOLA/HEVI DUTY
24VDC POWER
SUPPLY
POWER SUPPLY
24 VDC
2.5 AMP
12
417502
N404100
417512
417513
52
+ 417512
417513
14
54
02CBA4550
REF.
4305-20
UNIT 2 DSI SILO
SCALE 1
LOAD CELL 1
REF.
4305-24
UNIT 2 DSI SILO
SCALE 1
LOAD CELL 2
16
02CBA4554
REF.
4307-20
UNIT 2 DSI SILO
SCALE 2
LOAD CELL 1
02CBA4555
REF.
4307-24
UNIT 2 DSI SILO
SCALE 2
LOAD CELL 2
02CBA4556
REF.
4307-28
UNIT 2 DSI SILO
SCALE 2
LOAD CELL 3
56
CELL 1
SH
JP1
R
+
+
-
CELL 2
JP2
PT1
+
+
-
EXC
BK
IND
R
+
+
+
-
EXC
SIG
Y
EXC
BL
SEN
BK
SHLD
G
SIG
+
+
SIG
W
SHLD
SH
R
REF.
4305-28
02CBA4552
BK
+
+
SIG
SIG
SH
SHLD
Y
SHLD
SHLD
60
+
+
SIG
G
SIG
W
EXC
PT3
JP4
IND
R
+
+
+
-
EXC
EXC
BL
SEN
BK
EXC
Y
UNIT 2 DSI SILO
SCALE 1 LOAD CELL
SUMMING BOARD
CELL 3
JP3
Y
SHLD
G
SHLD
BK
SIG
W
SIG
+
+
SIG
SIG
SH
SHLD
SH
R
SEN
G
SIG
SHLD
W
EXC
EXC
62
W
SIG
EXC
Y
G
SIG
SEN
EXC
EXC
PT4
BK
EXC
EXP
+
+
+
-
SIG
EXC
CELL 4
EXC
SEN
SIG
SHLD
EXC
22
Y
SIG
SIG
SIG
SIG
SHLD
UNIT 2 DSI SILO
SCALE 1
LOAD CELL 3
+
+
-
EXC
G
W
SH
R
PT2
EXC
SIG
SEN
CELL 2
JP2
PT1
+
+
-
BK
58
W
JP1
R
SIG
EXC
Y
SEN
CELL 1
SH
G
SIG
SEN
EXC
SHLD
20
BK
EXC
EXP
+
+
+
-
SIG
W
02CBA4551
EXC
EXC
G
18
SH
R
PT2
Y
UNIT 2 DSI SILO
SCALE 2 LOAD CELL
SUMMING BOARD
EXC
PT4
CELL 4
PT3
JP4
CELL 3
JP3
REF.
4149-16
417513
R
+Exc
UNIT 2 DSI SILO
SCALE 2
WEIGH CONTROLLER
Prt Tx
Prt Rx
Prt
TR-
TR+
Term
Serial
Gnd
Shi
el
d
Gnd
+24V
+Exc
+Sen
+Si
g
-Si
g
-Sen
-Exc
+C2
-C2
G
BL
+Si
g
Y
W
-Sen
-Si
g
BK
+C2
+Sen
Shi
el
d
Shl
d
4-20mA
ETHERNET
414916
414916
+24V
02CBA4518
1-BK
TB3-5
Gnd
414917
Shield
1-W
REF.
4175-72
SHLD
1-SH
UNIT 2 DSI SILO
SCALE 1
GROSS WEIGHT
417570
417513
1A
TB3-2
TB3-3
414917
417512
417512
70
X SP
34
Weigh Scale Input
CB-417570
417530
1A
TB3-1
32
-Exc
Shi
el
d
CB-417530
417512
30
Gnd
Prt Tx
Prt Rx
DC Power
68
+24V
UNIT 2 DSI SILO
SCALE 1
WEIGH CONTROLLER
Prt
TR-
TR+
Term
Serial
Gnd
Shi
el
d
Gnd
+Exc
+Sen
+Si
g
-Si
g
-Sen
-Exc
+C2
+24V
+Si
g
+Exc
4-20mA
ETHERNET
-C2
-Si
g
+Sen
Weigh Scale Input
Shi
el
d
Shl
d
+24V
Gnd
DC Power
28
66
-C2
SHLD
R
G
BL
Y
W
-Sen
+C2
-Exc
26
-C2
64
Shi
el
d
24
BK
SHLD
HI 4050
TB3-4
REF.
4175-34
72
414956
414956
+24V
2-BK
TB3-8
414957
Shield
2-W
TB3-6
SHLD
UNIT 2 DSI SILO
SCALE 2
GROSS WEIGHT
TB3-9
SHLD
74
SHLD
2-SH
TB3-7
417513
Gnd
414957
TB3-10
417512
417513
120VAC & 24VDC POWER DISTRIBUTION
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4175
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4143-13
414300
414300
02CBD4299
02CBD4242
1-BK
X SP
TB2-1
N404100
2-R
TB2-2
414314
02
4-O
1-BK
X SP
UNIT 2 DSI SILO
EMERGENCY HIGH
LEVEL PROBE
40
REF.
4143-53
414340
414340
02CBD4252
02CBD4304
1-BK
X SP
N404100
414354
2-R
4-O
1-BK
TB2-9
TB2-3
X SP
414354
4-O
TB2-10
02CBD4302
TB2-1
TB2-2
1-BK
X SP
UNIT 2 DSI SILO
HIGH
LEVEL PROBE
414356
5-Y
5-Y
TB2-11
414358
414358
6-BR
6-BR
414316
4-O
TB2-12
414360
414300
02CBD4303
TB2-5
TB2-6
414318
1-BK
X SP
REF.
4303-16
UNIT 2 DSI SILO
MID
LEVEL PROBE
414362
2-R
8-BL/BK
414318
TB2-7
414508
50
4-O
414508
TB2-8
4-O
REF.
4175-06
UNIT 2 DSI SILO
START RELAY
414516
54
414516
02CBD4282
02CBD4305
4-O
X SP
4-O
TB2-16
X SP
N404100
N404100
2-R
2-R
TB2-17
414518
5-Y
16
REF.
4195-13
UNIT 2 DSI SILO
OPEN SOLENOID
UNIT 2 DSI SILO
OPEN SOLENOID
414518
5-Y
TB2-18
56
414520
6-BR
18
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414364
9-O/BK
TB2-15
52
REF.
4145-15
14
UNIT 2 DSI SILO
CLOSED LIMIT SWITCH
414362
8-BL/BK
TB2-14
414364
7-R/BK
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414360
7-R/BK
TB2-13
48
N404100
9-O/BK
12
UNIT 2 DSI SILO
CLOSED LIMIT SWITCH
46
7-R/BK
08
UNIT 2 DSI SILO
PANT LEG 2 LOW
LEVEL PROBE
44
2-R
5-Y
TB2-4
REF.
4303-10
414356
N404100
414316
6-BR
UNIT 2 DSI SILO
PANT LEG 1 LOW
LEVEL PROBE
42
4-O
414300
10
REF.
4195-00
414314
04
06
REF.
4303-04
UNIT 2 DSI SILO
FLUIDIZING BIN 1
SOLENOID
414520
6-BR
TB2-19
58
414522
7-R/BK
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
UNIT 2 DSI SILO
FLUIDIZING BIN 2
SOLENOID
414522
7-R/BK
TB2-20
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4176
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4143-27
414300
414300
02CBD4248
02CBD4306
1-BK
X SP
TB2-21
414328
4-O
1-BK
X SP
414328
TB2-22
4-O
REF.
4205-00
40
414340
02CBD4307
1-BK
1-BK
TB2-29
X SP
414368
4-O
414368
4-O
TB2-30
REF.
4215-00
EMERGENCY HIGH
LEVEL PROBE
42
414330
414330
5-Y
5-Y
TB2-23
LOW
LEVEL PROBE
04
414370
414370
5-Y
5-Y
TB2-31
LOW
LEVEL PROBE
44
414332
414332
6-BR
6-BR
TB2-24
ZERO SPEED SWITCH
06
414372
414372
6-BR
6-BR
TB2-32
ZERO SPEED SWITCH
46
414524
7-R/BK
414524
TB2-25
N404100
08
414340
02CBD4254
X SP
EMERGENCY HIGH
LEVEL PROBE
02
REF.
4143-67
2-R
AERATION
SOLENOID
414564
7-R/BK
N404100
TB2-26
414526
8-BL/BK
7-R/BK
414526
TB2-27
N404100
48
2-R
8-BL/BK
10
2-R
N404100
2-R
TB2-34
414566
8-BL/BK
AERATION
SOLENOID
414564
7-R/BK
TB2-33
414566
8-BL/BK
TB2-35
50
414528
9-O/BK
414528
TB2-28
9-O/BK
414568
9-O/BK
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
414568
9-O/BK
TB2-36
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4177
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4147-44
414740
414740
02CBA4500
02CBA4558
1-BK
X SP
414744
1-W
1-BK
TB3-11
X SP
1-SH
TB3-13
06
2-SH
TB3-15
TB3-16
3-W
3-SH
TB3-18
1-BK
X SP
TB3-19
1-W
X SP
50
1-SH
REF.
4205-32
1-BK
0 SP
PRESSURE
TRANSMITTER
52
1-W
TB3-22
414952
1-BK
TB3-23
54
1-SH
2-BK
REF.
4215-32
0 SP
PRESSURE
TRANSMITTER
56
414953
TB3-24
SHLD
2-SH
48
1-W
414952
2-W
UNIT 2 DSI SILO
SHLD
414953
18
REF.
4185-32
414913
TB3-21
SHLD
1-SH
1-BK
414912
TB3-20
414913
16
46
1-SH
SHLD
414912
REF.
4149-12
44
414752
SHLD
10
UNIT 2 DSI SILO
CONTINUOUS LEVEL
TRANSMITTER 2
1-W
414740
TB3-17
414752
14
X SP
02CBA4560
3-BK
REF.
4303-29
SHLD
414740
08
1-BK
414748
SHLD
12
42
1-SH
414740
TB3-14
414748
2-W
1-W
02CBA4559
2-BK
40
SHLD
414740
04
UNIT 2 DSI SILO
CONTINUOUS LEVEL
TRANSMITTER 1
414744
TB3-12
SHLD
02
REF.
4303-26
1-W
SHLD
TB3-25
1-SH
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4178
12
6"
12"
13
3"
1
14
C DOOR
L
21
15
22
16
17
A-CP4180
SILO D.C.
4"
20
DIFF. PRESSURE
7
8
9
3
C DOOR
L
2"
10"
6
CUT 4ƒ"
HOLE IN
DOOR
ZERO
NI
PO
TER ZER
O
SPAN
22
WARNING!
POWER FED FROM
MULTPLE SOURCES
5
4
10
11
3"
3"
1•"
2"
4•"
2"
BACKPANEL:
HOFFMAN A12P10
10.75"H x 8.88"W
2"
ENCLOSURE:
NEMA 4X, 304SS
HOFFMAN A12106CHNFSS
12.00"H x 10.00"W x 6.00"D
3"
3"
3"
3"
A-CP4180 SILO DUST COLLECTOR PANEL
PANEL LAYOUT
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/4"=1"
c
CATALOG NO.
65382
2007
DRAWING NO.
9190A-7-4180
10ƒ "
0"
2
18
0"
19
TESTED BY
24
26
A2
A1
28
23
DCT5XXA
FVN X.X.XX
XXXX
3•"
14
11
12
8‡"
27
25
ENCLOSURE:
NEMA 4X, 304SS
12.00"H x 10.00"W x 6.00"D
BACKPANEL:
HOFFMAN A12P10
10.75"H x 8.88"W
BACKPANEL LAYOUT
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1"=1"
c
CATALOG NO.
65382
2007
DRAWING NO.
9190A-7-4181
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 12" X 10" X 6" SS
HOFFMAN
MANUFACTURER
A-12106CHNFSS
PART No.
2
1
BACK PANEL, 10.75" X 8.88"
HOFFMAN
A-12P10
3
1
TRANSMITTER, PRESSURE, W/MAG GAUGE, RANGE 0-1.0" WC, 4-20MA OUTPUT PANEL MOUNT
DWYER
605-10
4
5
VALVE, SOLENOID, 1/8", 2 WAY, PILOT, PANEL MOUNTED
ASCO
P8262C2-120V
5
1
DRAIN/BREATHER, SS
CROUSE & HINDS
ECD15
6
2
CONNECTOR, 1/4"T X 1/4" NPT, SWVL 90
NORGEN
12-447-0428
7
2
CONNECTOR, 1/4"T X 1/4" NPT, M
NORGEN
12-425-0428
8
2
BULKHEAD, CONNECTOR, 1/4"T X 1/4"NPT, F, 316SS
PARKER FLUID CONNECTIONS
4-4-GH2BZ-SS
9
2
O-RING, 1/2" ID X 1/8" C/S 70 DURO, BLK COMPOUND #9746, VITON ACID RESIST
PRECISION ASSOCIATES
1-206-9746
10
9
CONNECTOR, 1/4"T X 1/8"NPT, M, 90, 316SS
PARKER FLUID CONNECTIONS
4-2-CBZ-SS
11
9
CONNECTOR, 1/4"T X 1/8"NPT, M
NORGEN
12-425-0418
12
1
BRACKET, MOUNTING, CONTROL ENCLOSURE, 304SS
NOL-TEC
238-12-304SS
13
4
SCREW, MACHINED, 10-32 X 3/4", MS, PLT
-
-
14
8
NUT, HEX HEAD, 1/4-20, MS, PLT
-
-
15
4
BOLT, HEX HEAD, 1/4-20 X 3/4", MS, PLT MINIMUM GRADE 5
-
-
16
4
LOCK WASHER, 1/4", MS, PLT
-
-
17
4
BOLT, HEX HEAD, 3/8-16 X 1/4", MS PLT MINIMUM GRADE 5
-
-
18
4
LOCK WASHER, 3/8", MS PLT
-
-
19
4
NUT, HEX HEAD, 3/8-16, MS, PLT
-
-
20
36"
POLYTUBING, 1/4", BLACK
NORGEN
1B-048-01
21
1
ENCLOSURE, MODIFICATION, SEND COVER TO SHOP TO CUT 4-3/4" DIA. HOLE
NOL-TEC
9115A-63 SHT. 2
22
3
PER PRINT/LIST
LEGEND
23
1
TIMER, 1-10 BANK, 102-132 VAC, 50/60HZ 50-500MSEC ON TIME, 1-180 SEC OFF
DWYER
DCT510A
24
1
RELAY, TERM. BLOCK, SPDT, 120 VAC/125 VDC, SLIM LINE BUILT IN LEAK CUR. SUPP. CIR., SCREW TERMS
ALLEN-BRADLEY
700-HLT1L1
25
1
TERMINAL BLOCK, 600V, 20A, STRIP OF 12
NEWARK ELECTRONICS
MOLEX 39100-0812
26
2
ALLEN-BRADLEY
1492-EAJ35
27
1
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
28
3"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65382
2007
DRAWING NO.
9190A-7-4182
No. Qty.
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
1
A-CP4180
.
ƒ" x 4•"
•"
WHITE
BLACK
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
SILO D.C.
DIFF. PRESSURE
1" x 3•"
WHITE
BLACK
‚"
JOB #9190A
120/1/60
1
A-CP4180
HOLES IN ENCLOSURE
MUST BE FILLED WITH
2
WARNING!
POWER FED FROM
MULTPLE SOURCES
COPPER WIRE WITH
3
60 DEG C INSULATION
SILO D.C.
DIFF. PRESSURE
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
LEGENDS
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65382
2007
DRAWING NO.
9190A-7-4183
WIRING LEGEND
- DENOTES PRE-WIRED
00
418501
40
CONNECT JUMPER TO
LAST CHANNEL USED
TB2
HIGH
LIMIT
COM
418502
02
LOW
LIMIT
OFF
TIME
JMPR1
ON
TIME
42
UNIT 2 DSI SILO
DUST COLLECTOR
TIMER BOARD
POWER
ON
04
44
TB2
FUSE
SOL
(+) (-) COM
1
2
3
4
5
6
7
8
9 10
3 AMP
(DO NOT USE
06
REF.
4175-05
N404100
08
46
SLOW BLOW FUSES)
417504
02CBD4301
1-BK
X SP
N404100
48
2-R
GND
10
50
3-BL
MOLEX
TB
414508
12
N404100
4-O
UNIT 2 DSI SILO
START RELAY
52
UNIT 2 DSI SILO
DUST COLLECTOR
SOLENOID 1
54
UNIT 2 DSI SILO
DUST COLLECTOR
SOLENOID 2
56
UNIT 2 DSI SILO
DUST COLLECTOR
SOLENOID 3
58
UNIT 2 DSI SILO
DUST COLLECTOR
SOLENOID 4
60
UNIT 2 DSI SILO
DUST COLLECTOR
SOLENOID 5
62
418513
418513
418514
14
418513
418516
16
418513
418518
18
418513
418520
20
418513
418522
22
MOLEX
TB
24
64
26
66
28
68
30
70
32
REF.
4178-08
414740
02CBA4560
1-BK
+
X SP
414752
1-W
-
DWYER
SERIES 605
MAGNEHELIC
UNIT 2 DSI SILO
72
SHLD
34
1-SH
74
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4185
8"
4"
6‡ "
0"
3‹ "
1
2
4
0"
5
TB1
A-JB4190
6
7
TB1 (20) 1492-J4
10"
7
WARNING!
POWER FED FROM
MULTPLE SOURCES
8
3
8ƒ"
ENCLOSURE:
NEMA 4X, 304SS
HOFFMAN A1008CHNFSS
10.00"H x 8.00"W x 4.00"D
BACKPANEL:
HOFFMAN A10P8
8.75"H x 6.88"W
A-JB4190 SILO PANT LEG JUNCTION BOX
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
1"=1"
c
CATALOG NO.
65364
2007
DRAWING NO.
9190A-7-4190
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 10" X 8" X 4", 304SS
HOFFMAN
MANUFACTURER
A1008CHNFSS
PART No.
2
1
BACK PANEL, 8.75" X 6.88"
HOFFMAN
A10P8
3
9"
DIN RAIL
ALLEN-BRADLEY
199-DR1
4
2
END ANCHOR, DIN RAIL, HEAVY DUTY
ALLEN-BRADLEY
1492-EAHJ35
5
1
END BARRIER (USED ON J3, J4, J6 & J10) GREY
ALLEN-BRADLEY
1492-EBJ3
6
20
ALLEN-BRADLEY
1492-J4
7
1
PER PRINT/LIST
LEGEND
8
1
GROUND BAR, 7 POINT
SQURED-D
PK7GTA
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65364
2007
DRAWING NO.
9190A-7-4192
TB1
414340
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
1
1
A-JB4190
.
ƒ" x 4•"
•"
WHITE
BLACK
2
HOLES IN ENCLOSURE
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
MUST BE FILLED WITH
4
No. Qty.
414354
414356
5
414358
6
1
414360
A-JB4190
7
414516
8
N404100
9
414362
10
414364
2
WARNING!
POWER FED FROM
MULTPLE SOURCES
11
COPPER WIRE WITH
12
60 DEG C INSULATION
414518
414520
13
14
414522
15
16
17
TERMINAL BLOCK
18
TIGHTENING TORQUE
19
1492-J4 - 9.0 LB-IN
20
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65364
2007
DRAWING NO.
9190A-7-4193
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4176-40
414340
414340
02CBD4304
02CBD4308
1-BK
X SP
TB1-1
1-BK
REF.
4304-04
40
X SP
N404100
TB1-2
414354
02
4-O
2-R
UNIT 2 DSI SILO
PANT LEG 1 LOW
LEVEL PROBE
414354
TB1-3
4-O
42
GND
3-BL
414340
04
02CBD4309
TB1-1
1-BK
REF.
4304-10
44
X SP
N404100
TB1-2
414356
06
5-Y
2-R
UNIT 2 DSI SILO
PANT LEG 2 LOW
LEVEL PROBE
414356
TB1-4
4-O
46
GND
3-BL
414340
08
02CBD4310
TB1-5
414358
6-BR
1-BK
REF.
4304-16
X SP
TB1-6
48
UNIT 2 DSI SILO
CLOSED LIMIT SWITCH
414358
4-O
10
50
414360
7-R/BK
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414360
TB1-7
5-Y
12
52
REF.
4176-53
414516
414516
02CBD4305
4-O
X SP
TB1-8
N404100
14
UNIT 2 DSI SILO
OPEN SOLENOID
2-R
6-BR
N404100
TB1-9
54
2-R
GND
3-BL
414340
16
02CBD4311
TB1-5
414362
8-BL/BK
1-BK
REF.
4304-21
X SP
TB1-10
56
UNIT 2 DSI SILO
CLOSED LIMIT SWITCH
414362
4-O
18
58
414364
9-O/BK
UNIT 2 DSI SILO
OPEN LIMIT SWITCH
414364
TB1-11
5-Y
20
60
414518
5-Y
UNIT 2 DSI SILO
OPEN SOLENOID
414518
TB1-12
6-BR
N404100
22
TB1-9
62
2-R
GND
3-BL
24
414520
414520
6-BR
1-BK
02CBD4312
TB1-13
REF.
4304-27
UNIT 2 DSI SILO
FLUIDIZING BIN 1
SOLENOID
REF.
4304-30
UNIT 2 DSI SILO
FLUIDIZING BIN 2
SOLENOID
X SP
64
N404100
TB1-14
2-R
GND
26
66
3-BL
414522
414522
02CBD4313
7-R/BK
TB1-15
1-BK
X SP
N404100
28
TB1-14
2-R
68
GND
3-BL
30
70
32
72
34
74
WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4195
10"
6"
5„"
3"
6
4
8‡ "
0"
5
4‹ "
7
1
0"
TB1
A-JB4200
4ƒ "
2
13
6„ "
SCALE 1
12
PRESSURE
15
(6) 1492-J4-B
11
16
&
ZERO
NI
PO
TER ZER
O
SPAN
16
TB1 (20) 1492-J4
14
2• "
12"
HIGH
LOW
8
3
17
WARNING!
POWER FED FROM
MULTPLE SOURCES
10ƒ"
9
10
ENCLOSURE:
NEMA 4X, 304SS
12.00"H x 10.00"W x 6.00"D
BACKPANEL:
HOFFMAN A12P10
10.75"H x 8.88"W
A-JB4200 SILO SCALE 1 JUNCTION BOX
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/4"=1"
c
CATALOG NO.
65365
2007
DRAWING NO.
9190A-7-4200
ITEM
QTY.
DESCRIPTION
1
1
HOFFMAN
MANUFACTURER
A12106CHNFSS
PART No.
2
1
BACK PANEL, 10.75" X 8.88"
HOFFMAN
A12P10
3
9"
DIN RAIL
ALLEN-BRADLEY
199-DR1
4
4
ALLEN-BRADLEY
1492-EAHJ35
5
1
ALLEN-BRADLEY
1492-EBJ3
6
20
ALLEN-BRADLEY
1492-J4
7
1
PER PRINT/LIST
LEGEND
8
1
GROUND BAR, 7 POINT
SQUARE-D
PK7GTA
9
6
ALLEN-BRADLEY
1492-J4-B
10
1
END BARRIER (USED ON J3, J4, J6 & J10) BLUE
ALLEN-BRADLEY
1492-EBJ3-B
11
1
TRANSMITTER, PRESSURE W/ MAG GAUGE, RANGE 0-10.0 IN WC, 4-20mA OUTPUT, PANEL MOUNT
DWYER
605-10
12
24"
NORGREN
1B-048-01
13
2
CONNECTOR, 1/4" T x 1/8" NPT, SWVL 90
NORGREN
12-447-0418
14
1
BULKHEAD, CONNECTOR, 1/4" NPT F, BRASS
PARKER
207ACBHS-4
15
1
BULKHEAD, CONNECTOR, 3/8"T x 1/4 NPT, MALE, 316SS
SWAGELOK
SS-600-11-4
16
2
CONNECTOR, 1/4"T x 1/4" NPT, M
NORGREN
12-425-0428
17
1
MUFFLER, 1/4" SINTERED BRONZE
NUMATICS
P2MN
BILL OF MATERIAL
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65365
2007
DRAWING NO.
9190A-7-4202
TB1
414300
No. Qty.
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
1
A-JB4200
.
ƒ" x 4•"
•"
WHITE
BLACK
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
SCALE 1
PRESSURE
1" x 3•"
‚"
WHITE
BLACK
1
N404100
2
HOLES IN ENCLOSURE
3
MUST BE FILLED WITH
4
414328
414330
5
414332
6
414524
7
1
A-JB4200
8
414526
9
414528
10
2
WARNING!
POWER FED FROM
MULTPLE SOURCES
11
COPPER WIRE WITH
12
60 DEG C INSULATION
13
14
15
16
17
TERMINAL BLOCK
18
TIGHTENING TORQUE
19
3
SCALE 1
PRESSURE
1492-J4 - 9.0 LB-IN
20
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
414912
21
414913
22
SHLD
23
24
U
L
25
R
26
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65365
2007
DRAWING NO.
9190A-7-4203
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4177-00
414300
414300
02CBD4306
02CBD4314
1-BK
X SP
TB1-1
N404100
2-R
4-O
40
X SP
N404100
TB1-2
414328
02
1-BK
REF.
4306-00
2-R
EMERGENCY HIGH
LEVEL PROBE
414328
TB1-3
4-O
42
GND
3-BL
414300
04
02CBD4315
TB1-1
1-BK
REF.
4306-06
44
X SP
N404100
TB1-2
414330
06
5-Y
2-R
LOW
LEVEL PROBE
414330
TB1-4
4-O
46
GND
3-BL
414300
08
02CBD4316
TB1-5
414332
6-BR
1-BK
REF.
4307-04
X SP
TB1-6
48
ZERO SPEED SWITCH
414332
2-R
10
50
414524
414524
02CBD4319
7-R/BK
TB1-7
1-BK
REF.
4306-12
X SP
AERATION
SOLENOID
N404100
12
TB1-8
52
2-R
GND
3-BL
14
414526
414526
8-BL/BK
1-BK
02CBD4320
TB1-9
REF.
4307-07
REF.
4307-11
X SP
54
N404100
TB1-8
2-R
GND
16
56
3-BL
414528
414528
02CBD4321
9-O/BK
TB1-10
1-BK
X SP
N404100
18
TB1-11
58
2-R
GND
3-BL
20
60
22
62
24
64
26
66
28
68
30
70
32
414912
REF.
4178-12
1-BK
0 SP
414912
TB1-21
414913
1-W
414913
TB1-22
SHLD
34
1-SH
+
-
DWYER
SERIES 605
MAGNEHELIC
DIFFERENTIAL
72
SHLD
74
TB1-23
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4205
10"
6"
5„"
3"
6
4
8‡ "
0"
5
4‹ "
7
1
0"
TB1
A-JB4210
4ƒ "
2
13
6„ "
SCALE 2
12
PRESSURE
15
(6) 1492-J4-B
11
16
&
ZERO
NI
PO
TER ZER
O
SPAN
16
TB1 (20) 1492-J4
14
2• "
12"
HIGH
LOW
8
3
17
WARNING!
POWER FED FROM
MULTPLE SOURCES
10ƒ"
9
10
ENCLOSURE:
NEMA 4X, 304SS
12.00"H x 10.00"W x 6.00"D
BACKPANEL:
HOFFMAN A12P10
10.75"H x 8.88"W
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/4"=1"
c
CATALOG NO.
65366
2007
DRAWING NO.
9190A-7-4210
ITEM
QTY.
DESCRIPTION
1
1
HOFFMAN
MANUFACTURER
A12106CHNFSS
PART No.
2
1
BACK PANEL, 10.75" X 8.88"
HOFFMAN
A12P10
3
9"
DIN RAIL
ALLEN-BRADLEY
199-DR1
4
4
ALLEN-BRADLEY
1492-EAHJ35
5
1
ALLEN-BRADLEY
1492-EBJ3
6
20
ALLEN-BRADLEY
1492-J4
7
1
PER PRINT/LIST
LEGEND
8
1
GROUND BAR, 7 POINT
SQUARE-D
PK7GTA
9
6
ALLEN-BRADLEY
1492-J4-B
10
1
END BARRIER (USED ON J3, J4, J6 & J10) BLUE
ALLEN-BRADLEY
1492-EBJ3-B
11
1
TRANSMITTER, PRESSURE W/ MAG GAUGE, RANGE 0-10.0 IN WC, 4-20mA OUTPUT, PANEL MOUNT
DWYER
605-10
12
24"
NORGREN
1B-048-01
13
2
CONNECTOR, 1/4" T x 1/8" NPT, SWVL 90
NORGREN
12-447-0418
14
1
BULKHEAD, CONNECTOR, 1/4" NPT F, BRASS
PARKER
207ACBHS-4
15
1
BULKHEAD, CONNECTOR, 3/8"T x 1/4 NPT, MALE, 316SS
SWAGELOK
SS-600-11-4
16
2
CONNECTOR, 1/4"T x 1/4" NPT, M
NORGREN
12-425-0428
17
1
MUFFLER, 1/4" SINTERED BRONZE
NUMATICS
P2MN
BILL OF MATERIAL
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65366
2007
DRAWING NO.
9190A-7-4212
TB1
414340
No. Qty.
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
1
1
A-JB4210
.
ƒ" x 4•"
•"
WHITE
BLACK
2
1
*SEE LEGEND*
.
1‚" x 4"
‚"
WHITE
BLACK
3
1
SCALE 2
PRESSURE
1" x 3•"
‚"
WHITE
BLACK
1
N404100
2
HOLES IN ENCLOSURE
3
MUST BE FILLED WITH
4
414368
414370
5
414372
6
414564
7
1
A-JB4210
8
414566
9
414568
10
2
WARNING!
POWER FED FROM
MULTPLE SOURCES
11
COPPER WIRE WITH
12
60 DEG C INSULATION
13
14
15
16
17
TERMINAL BLOCK
18
TIGHTENING TORQUE
19
3
SCALE 2
PRESSURE
1492-J4 - 9.0 LB-IN
20
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
414952
21
414953
22
SHLD
23
24
U
L
25
R
26
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
OWENSBORO, KY
0
REV
01JUN15
DATE
REVISION NOTE
JSA
DRAWN
ADH
DESIGN
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65366
2007
DRAWING NO.
9190A-7-4213
WIRING LEGEND
- DENOTES PRE-WIRED
00
REF.
4177-40
414340
414340
02CBD4307
02CBD4322
1-BK
X SP
TB1-1
N404100
2-R
4-O
40
X SP
N404100
TB1-2
414368
02
1-BK
REF.
4308-00
2-R
EMERGENCY HIGH
LEVEL PROBE
414368
TB1-3
4-O
42
GND
3-BL
414340
04
02CBD4323
TB1-1
1-BK
REF.
4308-06
44
X SP
N404100
TB1-2
414370
06
5-Y
2-R
LOW
LEVEL PROBE
414370
TB1-4
4-O
46
GND
3-BL
414340
08
02CBD4324
TB1-5
414372
6-BR
1-BK
REF.
4309-04
X SP
TB1-6
48
ZERO SPEED SWITCH
414372
2-R
10
50
414564
414564
02CBD4327
7-R/BK
TB1-7
1-BK
REF.
4308-12
X SP
AERATION
SOLENOID
N404100
12
TB1-8
52
2-R
GND
3-BL
14
414566
414566
8-BL/BK
1-BK
02CBD4328
TB1-9
REF.
4309-07
REF.
4309-11
X SP
54
N404100
TB1-8
2-R
GND
16
56
3-BL
414568
414568
02CBD4329
9-O/BK
TB1-10
1-BK
X SP
N404100
18
TB1-11
58
2-R
GND
3-BL
20
60
22
62
24
64
26
66
28
68
30
70
32
414952
REF.
4178-16
1-BK
X SP
414952
TB1-21
414953
1-W
414953
TB1-22
SHLD
34
1-SH
+
-
DWYER
SERIES 605
MAGNEHELIC
DIFFERENTIAL
72
SHLD
74
TB1-23
WIRING DIAGRAM
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4215
36"
12"
1
A-CP4220
36"
3
ENCLOSURE:
NEMA 4X, 304SS
36.00"H x 36.00"W x 12.00"D
BACKPANEL:
HOFFMAN A36P36
33.00"H x 33.00"W
A-CP4220 DUCT 1 REMOTE I/O PANEL
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65383
2007
DRAWING NO.
9190A-7-4220
6
9
6
33"
6
8
28… "
6
7
23† "
6
8
20„ "
7
16ƒ "
10„ "
2
6† "
0"
6
5
10
0"
9
1
7
6
3•"
0
8
ALLEN-BRADLEY
1794-AENT
MODULE STATUS
5
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
0
1
2
3
6
5
4
NETWORK STATUS
LINK STATUS
7"
24
3" x 4" WIREWAY
CB
CB
CB
16
17
CB
25
21
CB
16
CB
16
CB
16
27
CB
16
CB
16
3" x 4" W I
REW AY
CB
TB2 (35) 1492-J4
CB
TB3
LNK
TX
RX
100
BaseFX
12
13
N L
1" x 4" W I
REW AY
CB
10/100
102M C
16
3" x 4" W I
REW AY
(31) 1492-J4
TB1 (2) 1492-J6,(1) 1492-JG6 &
3" x 4" W I
REW AY
22"
23
CB
18
- -
21
15
+ +
17
CB
CB
11
CB
TB3 (10) 1492-J4-B
CB
16
25
1" x 4" W I
REW AY
CB
20
CB
BaseTX
TB2
14
SOLA
POW ER SUPPLY
SDN 2.5-24-100P
TB1
19
ACT
25
CB
CB
CB
16
17
CB
CB
26
22
1" x 4" WIREWAY
29
CLEAR AREA
30
28
4
ELECTRIC HEATER
3" x 4" WIREWAY
33"
ENCLOSURE:
NEMA 4X, 304SS
36.00"H x 36.00"W x 12.00"D
BACKPANEL:
HOFFMAN A36P36
33.00"H x 33.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65383
2007
DRAWING NO.
9190A-7-4221
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 36" X 36" X 12", 304SS SINGLE DOOR
HOFFMAN
MANUFACTURER
A-36H3612SSLP
PART No.
2
1
BACK PANEL, 33.00" X 33.00"
HOFFMAN
A-36P36
3
1
PER PRINT/LIST
LEGEND
4
1
HOFFMAN
DAH2001A
5
1
FLEX I/O ETHERNET ADAPTER MODULE W/24VDC POWER SUPPLY
ALLEN-BRADLEY
1794-AENT
6
8
FLEX I/O TERMINAL WIRING BASE
ALLEN-BRADLEY
1794-TB3
7
2
FLEX I/O 16-POINT, 120 VAC, INPUT MODULE
ALLEN-BRADLEY
1794-IA16
8
3
FLEX I/O, ISOLATED OUTPUT MODULE, 120 VAC, 8 POINT
ALLEN-BRADLEY
1794-OA8I
9
1
FLEX I/O, 16-POINT, 120VAC, OUTPUT MODULE
ALLEN-BRADLEY
1794-OA16
10
2
FLEX I/O, INPUT MODULE, ANALOG, 24 VDC, 8 SINGLE ENDED INPUTS
ALLEN-BRADLEY
1794-IE8
11
1
CONVERTER, MEDIA, (1)10/100 COPPER TO (1) FIBER, ST CONNECTOR, 24 VDC
N-TRON
102MC-ST
12
1
BELDEN
5FTCAT5EPATCH
13
1
SOLA
SDN 2.5-24-100P
14
1
ALLEN-BRADLEY
1489-M1C200
15
1
ALLEN-BRADLEY
1489-M1C050
16
10
ALLEN-BRADLEY
1489-M1C030
17
13
ALLEN-BRADLEY
1489-M1C020
18
1
ALLEN-BRADLEY
1489-M1C010
19
2
ALLEN-BRADLEY
1492-J6
20
1
ALLEN-BRADLEY
1492-JG6
21
67
ALLEN-BRADLEY
1492-J4
22
10
ALLEN-BRADLEY
1492-J4-B
23
1
ALLEN-BRADLEY
1492-CJJ6-10
24
8
ALLEN-BRADLEY
1492-EAJ35
25
11
ALLEN-BRADLEY
1492-EBJ3
26
2
ALLEN-BRADLEY
1492-EBJ3-B
27
2
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
28
110"
PHOENIX CONTACT
CD-HF 80X100 3240360
29
40"
PHOENIX CONTACT
CD-HF 30X100 3240347
30
90"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65383
2007
DRAWING NO.
9190A-7-4222
TB1
TB2
TB3
H403608
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-CP4220
.
ƒ" x 4•"
•"
WHITE
BLACK
422516
1
1
2
2
422604
GND
422640
3
3
422502
423014
422504
423016
422540
423055
4
6
423000
5
5
6
6
423054
AMP
2
AMP
423340
TB1-6
5
AMP
422603
7
7
TB1-7
8
8
TB1-8 - TB1-13
2
AMP
9
9
TB1-24
3
AMP
10
10
TB1-32
3
AMP
7
422540
20
TB1-5
4
422640
5
422600
TB1-4
423300
3
422642
4
422502
CB & FUSE CHART
422606
2
423000
H403608
A-CP4220
422604
1
N403608
1
422602
423056
8
423040
422518
9
423100
10
423140
423000
423200
423018
11
11
12
423240
12
TB1-40
3
AMP
13
13
TB2-1
3
AMP
14
14
TB2-9
3
AMP
15
15
TB2-17
3
AMP
423103
14
423102
15
AMP
12
423020
13
N403608
11
422604
1
423104
16
16
17
17
16
TB2-25
3
AMP
18
TB2-33
3
AMP
19
TB3-1
3
AMP
TB3-2
3
AMP
22
TB3-3
2
AMP
23
TB3-4
2
AMP
TB3-5 - TB3-6
2
AMP
422520
18
422502
423000
19
423022
20
20
423024
21
21
423107
22
423106
23
422510
423108
24
24
422522
25
25
26
26
423000
423002
423000
27
27
423004
423026
28
28
423043
423028
29
JOB #9190A
29
423042
423111
30
30
423044
120/1/60
423110
31
31
422512
423112
32
32
422524
33
33
34
34
423000
423006
423000
35
35
423008
423030
36
36
423047
423032
37
37
423046
HOLES IN ENCLOSURE
423115
38
38
423048
423114
39
422514
40
39
MUST BE FILLED WITH
40
423116
41
423000
42
423010
43
423012
44
423051
45
423050
46
423052
48
COPPER WIRE WITH
49
60 DEG C INSULATION
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
TB2
TB3
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65383
2007
DRAWING NO.
9190A-7-4223
422502
N403608
WIRING LEGEND
- DENOTES PRE-WIRED
CB-422540
GND
REF.
4036-08
00
422502
40
02CBD4097
3-BL
TB1-3
0 SP
422540
5A
TB1-6
POWER FOR
DIGITAL INPUT &
OUTPUT CARDS
N403608
TB1-14
120VDC POWER
TO DIGITAL
INPUTS & OUTPUTS
CB-422502
422502
02
H403608
20A
TB1-4
H403608
N403608
1-BK
2-R
TB1-1
N403608
42
TB1-2
CB-422504
422502
04
422504
2A
TB1-5
N403608
H
HEATER
N403608
N
TB1-14
120VAC POWER TO
ENCLOSURE
HEATER
44
06
46
08
48
CB-422510
422502
10
3A
TB1-24
CB-422512
422516
N403608
1-BK
2-R
422518
N403608
1-BK
2-R
TB2-2
422520
N403608
1-BK
2-R
TB2-10
422522
N403608
1-BK
2-R
TB2-18
TB2-26
REF.
4230-29
422524
N403608
1-BK
2-R
N403608
TB2-34
02CBD4077
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 4 MOV
56
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 5 MOV
58
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 6 MOV
60
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 7 MOV
62
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 8 MOV
64
REF.
4311-19
X SP
3A
TB2-33
54
REF.
4311-10
N403608
02CBD4076
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 3 MOV
REF.
4311-00
N403608
02CBD4075
52
REF.
4310-29
N403608
02CBD4074
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 2 MOV
REF.
4310-19
N403608
02CBD4073
REF.
4230-25
422502
24
TB1-41
X SP
3A
TB2-25
CB-422524
N403608
02CBD4072
REF.
4230-21
422502
22
2-R
X SP
3A
TB2-17
CB-422522
N403608
1-BK
REF.
4230-17
422502
20
422514
50
REF.
4310-10
X SP
3A
TB2-9
CB-422520
N403608
TB1-33
02CBD4071
REF.
4230-13
422502
18
2-R
X SP
3A
TB2-1
CB-422518
1-BK
REF.
4230-09
422502
16
N403608
120VAC POWER TO
UNIT 2 DSI DUCT 1
LANCE 1 MOV
REF.
4310-00
X SP
3A
TB1-40
CB-422516
N403608
TB1-25
02CBD4070
422512
REF.
4230-05
422502
14
2-R
X SP
3A
TB1-32
CB-422514
N403608
1-BK
REF.
4230-01
422502
12
422510
REF.
4311-29
X SP
26
66
28
68
30
70
32
72
34
74
422502
N403608
422502
N403608
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4225
422502
N403608
422604
422603
WIRING LEGEND
- DENOTES PRE-WIRED
CB-422600
422502
00
CB-422640
422600
N403608
422604
40
1A
TB1-7
POWER FOR
ANALOG INPUT &
OUTPUT CARDS
422640
2A
TB3-3
422603
TB3-8
24VDC POWER
FOR ANALOG
INPUTS & OUTPUTS
L N G
CB-422642
SOLA/HEVI DUTY
24VDC POWER
SUPPLY
POWER SUPPLY
24 VDC
2.5 AMP
02
422642
2A
TB3-4
H
ALLEN-BRADLEY
1794-AENT
422603
N
TB3-8
G
ALLEN-BRADLEY
1794-AENT
ETHERNET MODULE
+ -
CB-422604
422604
04
422604
42
422602
422603
44
3A
TB3-1
TB3-7
CB-422606
422604
06
422606
3A
TB3-2
+
NTRON
MEDIA
CONVERTER
422603
G
TB3-7
N-TRON
MEDIA
CONVERTER
46
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
422604
422603
422604
422603
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4226
422540
N403608
422540
N403608
REF.
4225-11
C35
423000
02
TB1-26
40
UNIT 2 DSI DUCT 1
LANCE 1 MOV
CLOSED LIMIT SWITCH
42
REF.
4230-42
423000
423002
4-O
5-Y
423002
TB1-27
C:00:I.00
A0
DATA[0].00
2A
TB1-9
B16
ALLEN-BRADLEY 1794-IA16/
1794-TB3 120VAC INPUT
RACK C, MODULE 0
CB-423040
1794-IA16/
1794-TB3
2A
TB1-8
00
CB-423000
WIRING LEGEND
- DENOTES PRE-WIRED
1794-OA8I/
B16
C:01:O.00
423042
423042
TB1-30
8-BL/BK
423043
423043
TB1-29
423044
423044
TB1-31
9-O/BK
UNIT 2 DSI DUCT 1
LANCE 1 MOV
OPEN COMMAND
REF.
4230-01
A0
DATA[1].00
ALLEN-BRADLEY 1794-OA8I/
1794-TB3 120VAC ISO. OUTPUT
RACK C, MODULE 1
1794-TB3
A1
C36
423004
04
6-BR
REF.
4225-13
C37
423000
06
TB1-34
423004
TB1-28
C:00:I.01
A1
DATA[0].01
UNIT 2 DSI DUCT 1
LANCE 1 MOV
OPEN LIMIT SWITCH
C:00:I.02
A2
DATA[0].02
UNIT 2 DSI DUCT 1
LANCE 2 MOV
CLOSED LIMIT SWITCH
C:01:O.01
44
DATA[1].01
REF.
4230-46
423000
423006
4-O
5-Y
7-R/BK
UNIT 2 DSI DUCT 1
LANCE 1 MOV
CLOSE COMMAND
A2
A3
423006
TB1-35
C:01:O.02
46
423046
423046
TB1-38
423047
UNIT 2 DSI DUCT 1
LANCE 2 MOV
OPEN COMMAND
REF.
4230-05
A4
DATA[1].02
8-BL/BK
423047
A5
C38
423008
08
6-BR
REF.
4225-15
C39
423000
10
TB1-42
423008
TB1-36
C:00:I.03
A3
DATA[0].03
UNIT 2 DSI DUCT 1
LANCE 2 MOV
OPEN LIMIT SWITCH
C:00:I.04
A4
DATA[0].04
UNIT 2 DSI DUCT 1
LANCE 3 MOV
CLOSED LIMIT SWITCH
C:01:O.03
48
423010
4-O
5-Y
423048
TB1-39
9-O/BK
UNIT 2 DSI DUCT 1
LANCE 2 MOV
CLOSE COMMAND
A6
DATA[1].03
REF.
4230-50
423000
7-R/BK
TB1-37
423048
A7
423010
TB1-43
C:01:O.04
50
423050
423050
TB1-46
423051
UNIT 2 DSI DUCT 1
LANCE 3 MOV
OPEN COMMAND
REF.
4230-09
A8
DATA[1].04
8-BL/BK
423051
A9
C40
423012
12
6-BR
REF.
4225-17
C41
423000
14
TB2-3
423012
TB1-44
C:00:I.05
A5
DATA[0].05
UNIT 2 DSI DUCT 1
LANCE 3 MOV
OPEN LIMIT SWITCH
C:00:I.06
A6
DATA[0].06
UNIT 2 DSI DUCT 1
LANCE 4 MOV
CLOSED LIMIT SWITCH
C:01:O.05
52
423014
4-O
5-Y
7-R/BK
UNIT 2 DSI DUCT 1
LANCE 3 MOV
CLOSE COMMAND
423052
A10
DATA[1].05
REF.
4230-54
423000
TB1-45
423052
TB1-47
9-O/BK
A11
423014
TB2-4
C:01:O.06
54
423054
423054
TB2-7
423055
8-BL/BK
DATA[1].06
UNIT 2 DSI DUCT 1
LANCE 4 MOV
OPEN COMMAND
REF.
4230-13
A12
423055
A13
C42
423016
16
6-BR
REF.
4225-19
C43
423000
18
TB2-11
423018
4-O
5-Y
6-BR
REF.
4225-21
423000
22
TB2-19
423022
4-O
5-Y
C46
REF.
4225-23
423000
26
TB2-27
423026
4-O
5-Y
C48
6-BR
423000
30
TB2-35
C50
32
DATA[1].07
TB2-13
C:00:I.08
A8
DATA[0].08
UNIT 2 DSI DUCT 1
LANCE 5 MOV
CLOSED LIMIT SWITCH
58
C:00:I.09
A9
DATA[0].09
UNIT 2 DSI DUCT 1
LANCE 5 MOV
OPEN LIMIT SWITCH
60
423022
C:00:I.10
A10
DATA[0].10
UNIT 2 DSI DUCT 1
LANCE 6 MOV
CLOSED LIMIT SWITCH
TB2-20
62
423024
C:00:I.11
A11
DATA[0].11
UNIT 2 DSI DUCT 1
LANCE 6 MOV
OPEN LIMIT SWITCH
TB2-21
64
423026
C:00:I.12
A12
DATA[0].12
UNIT 2 DSI DUCT 1
LANCE 7 MOV
CLOSED LIMIT SWITCH
TB2-28
66
423028
C:00:I.13
A13
DATA[0].13
UNIT 2 DSI DUCT 1
LANCE 7 MOV
OPEN LIMIT SWITCH
TB2-29
68
423000
423030
4-O
5-Y
423032
423030
TB2-36
C:00:I.14
A14
DATA[0].14
UNIT 2 DSI DUCT 1
LANCE 8 MOV
CLOSED LIMIT SWITCH
70
423032
TB2-37
C:00:I.15
A15
DATA[0].15
UNIT 2 DSI DUCT 1
LANCE 8 MOV
OPEN LIMIT SWITCH
72
UNIT 2 DSI DUCT 1
LANCE 4 MOV
CLOSE COMMAND
C34
74
C34
423000
TB2-8
9-O/BK
REF.
4231-14
6-BR
34
423020
423028
REF.
4225-25
7-R/BK
423056
A14
REF.
4231-10
423000
28
C49
TB2-12
423024
6-BR
C47
56
TB2-6
423056
REF.
4231-06
423000
24
C:01:O.07
A15
423018
423020
20
C45
TB2-5
UNIT 2 DSI DUCT 1
LANCE 4 MOV
OPEN LIMIT SWITCH
REF.
4231-02
423000
C44
423016
C:00:I.07
A7
DATA[0].07
N403608
N403608
423040
I/O WIRING DIAGRAM, RACK C SLOTS 0 & 1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4230
422540
N403608
422540
N403608
1794-TB3 120VAC ISO. OUTPUT 40
RACK C, MODULE 2
1794-TB3
B16
C:02:O.00
02
423102
423102
A0
DATA[2].00
TB2-15
8-BL/BK
423103
423103
TB2-14
423104
7-R/BK
TB2-16
9-O/BK
REF.
4230-17
UNIT 2 DSI DUCT 1
LANCE 5 MOV
OPEN COMMAND
42
UNIT 2 DSI DUCT 1
LANCE 5 MOV
CLOSE COMMAND
44
UNIT 2 DSI DUCT 1
LANCE 6 MOV
OPEN COMMAND
46
UNIT 2 DSI DUCT 1
LANCE 6 MOV
CLOSE COMMAND
48
UNIT 2 DSI DUCT 1
LANCE 7 MOV
OPEN COMMAND
50
UNIT 2 DSI DUCT 1
LANCE 7 MOV
CLOSE COMMAND
52
UNIT 2 DSI DUCT 1
LANCE 8 MOV
OPEN COMMAND
54
UNIT 2 DSI DUCT 1
LANCE 8 MOV
CLOSE COMMAND
56
1794-IA16/
1794-TB3
2A
TB1-11
1794-OA8I/
CB-423140
2A
TB1-10
00
CB-4224230
WIRING LEGEND
- DENOTES PRE-WIRED
B16
RACK C, MODULE 3
C35
C:03:I.00
A0
DATA[3].00
SPARE
INPUT
C36
C:03:I.01
A1
DATA[3].01
SPARE
INPUT
C37
C:03:I.02
A2
DATA[3].02
SPARE
INPUT
C38
C:03:I.03
A3
DATA[3].03
SPARE
INPUT
C39
C:03:I.04
A4
DATA[3].04
SPARE
INPUT
C40
C:03:I.05
A5
DATA[3].05
A1
C:02:O.01
04
423104
A2
DATA[2].01
A3
C:02:O.02
06
423106
423106
A4
DATA[2].02
TB2-23
423107
8-BL/BK
REF.
4230-21
423107
A5
C:02:O.03
08
TB2-22
423108
7-R/BK
423108
A6
DATA[2].03
TB2-24
9-O/BK
A7
C:02:O.04
10
423110
423110
A8
DATA[2].04
TB2-31
423111
8-BL/BK
REF.
4230-25
423111
A9
C:02:O.05
12
TB2-30
423112
7-R/BK
423112
A10
DATA[2].05
TB2-32
9-O/BK
SPARE
INPUT
A11
C:02:O.06
14
423114
423114
A12
DATA[2].06
TB2-39
423115
8-BL/BK
TB2-38
423116
7-R/BK
TB2-40
9-O/BK
REF.
4230-29
C41
C:03:I.06
A6
DATA[3].06
SPARE
INPUT
C42
C:03:I.07
A7
DATA[3].07
SPARE
INPUT
C43
C:03:I.08
A8
DATA[3].08
SPARE
INPUT
C44
C:03:I.09
A9
DATA[3].09
SPARE
INPUT
C45
C:03:I.10
A10
DATA[3].10
SPARE
INPUT
C46
C:03:I.11
A11
DATA[3].11
SPARE
INPUT
C47
C:03:I.12
A12
DATA[3].12
SPARE
INPUT
C48
C:03:I.13
A13
DATA[3].13
SPARE
INPUT
C49
C:03:I.14
A14
DATA[3].14
SPARE
INPUT
C50
C:03:I.15
A15
DATA[3].15
SPARE
INPUT
423115
A13
C:02:O.07
16
423116
A14
DATA[2].07
A15
18
58
C34
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
4224230
N403608
C34
N403608
423140
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4231
422540
N403608
422540
N403608
1794-TB3
B16
C:04:O.00
02
A0
DATA[4].00
RACK C, MODULE 4
SPARE
OUTPUT
2A
TB1-13
1794-OA8I/
CB-423240
2A
TB1-12
00
CB-423200
WIRING LEGEND
- DENOTES PRE-WIRED
1794-OA16/
B16
C:05:O.00
42
423242
N403608
1-BK
2-R
A1
C:04:O.01
04
A2
DATA[4].01
02CBD4400
SPARE
OUTPUT
C:04:O.02
A4
DATA[4].02
C:05:O.01
44
423244
N403608
1-BK
2-R
C:04:O.03
A6
DATA[4].03
C:05:O.02
46
423246
N403608
1-BK
2-R
C:04:O.04
A8
DATA[4].04
C:05:O.03
48
423248
N403608
1-BK
2-R
C:04:O.05
A10
DATA[4].05
C:05:O.04
50
423250
N403608
1-BK
2-R
14
A12
C:05:O.05
52
423252
N403608
1-BK
2-R
DATA[4].06
C:05:O.06
16
A14
54
423254
N403608
1-BK
2-R
DATA[4].07
DATA[5].06
C:05:O.07
56
423256
N403608
1-BK
2-R
B24
UNIT 2 DSI DUCT 1 LANCE 8
PURGE SOLENOID
A7
DATA[5].07
02CBD4407
C:05:O.08
58
C34
PURGE SOLENOID
REF.
4312-20
X SP
A15
18
B23
A6
02CBD4406
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-16
X SP
A13
C:04:O.07
B22
A5
DATA[5].05
02CBD4405
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-13
X SP
A11
C:04:O.06
B21
A4
DATA[5].04
02CBD4404
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-10
X SP
A9
12
B20
A3
DATA[5].03
02CBD4403
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-06
X SP
A7
10
B19
A2
DATA[5].02
02CBD4402
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-03
X SP
A5
08
B18
A1
DATA[5].01
02CBD4401
SPARE
OUTPUT
PURGE SOLENOID
REF.
4312-23
X SP
B25
A8
DATA[5].08
B26
C:05:O.09
20
60
A9
DATA[5].09
B27
C:05:O.10
22
62
A10
DATA[5].10
B28
C:05:O.11
24
64
A11
DATA[5].11
B29
C:05:O.12
26
66
A12
DATA[5].12
B30
C:05:O.13
28
68
A13
DATA[5].13
B31
C:05:O.14
30
70
A14
DATA[5].14
B32
C:05:O.15
32
72
A15
DATA[5].15
34
74
423200
N403608
REF.
4312-00
X SP
A3
06
B17
A0
DATA[5].00
ALLEN-BRADLEY 1794-OA16/
1794-TB3 120VAC OUTPUT
RACK C, MODULE 5
1794-TB3
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
C34
N403608
423240
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4232
422640
422603
422640
422603
40
423300
1-BK
C35
REF.
4313-00
02
C:06:I.CH0
1794-IE8/
1794-TB3
2A
TB3-6
B16
ALLEN-BRADLEY 1794-IE8/
1794-TB3 ANALOG INPUT
RACK C, MODULE 6
CB-423340
1794-IE8/
1794-TB3
2A
TB3-5
00
CB-423300
WIRING LEGEND
- DENOTES PRE-WIRED
B16
RACK C, MODULE 7
C:07:I.CH0
C35
423302
1-W
X SP
SHLD
1-SH
42
A0
(I0)
02CBA4580
CH0DATA
C39
04
A0
(I0)
UNIT 2 DSI DUCT 1
LANCE 1
CH0DATA
C39
44
A1
(V0)
SPARE
ANALOG
INPUT
A1
(V0)
423300
1-BK
C37
REF.
4313-03
06
C:06:I.CH1
C:07:I.CH1
C37
423306
1-W
X SP
SHLD
1-SH
46
A2
(I1)
02CBA4581
CH1DATA
C40
08
A2
(I1)
UNIT 2 DSI DUCT 1
LANCE 2
CH1DATA
C40
48
A3
(V1)
SPARE
ANALOG
INPUT
A3
(V1)
423300
1-BK
C39
REF.
4313-06
10
C:06:I.CH2
C:07:I.CH2
C39
423310
1-W
X SP
SHLD
1-SH
50
A4
(I2)
02CBA4582
CH2DATA
C41
12
A4
(I2)
UNIT 2 DSI DUCT 1
LANCE 3
CH2DATA
C41
52
A5
(V2)
SPARE
ANALOG
INPUT
A5
(V2)
423300
1-BK
C41
REF.
4313-09
14
C:06:I.CH3
C:07:I.CH3
C41
423314
1-W
X SP
SHLD
1-SH
54
A6
(I3)
02CBA4583
CH3DATA
C42
16
A6
(I3)
UNIT 2 DSI DUCT 1
LANCE 4
CH3DATA
C42
56
A7
(V3)
SPARE
ANALOG
INPUT
A7
(V3)
423300
1-BK
C43
REF.
4313-12
18
C:06:I.CH4
C:07:I.CH4
C43
423318
1-W
X SP
SHLD
1-SH
58
A8
(I4)
02CBA4584
CH4DATA
C43
20
A8
(I4)
UNIT 2 DSI DUCT 1
LANCE 5
CH4DATA
C43
60
A9
(V4)
SPARE
ANALOG
INPUT
A9
(V4)
423300
1-BK
C45
REF.
4313-15
22
C:06:I.CH5
C:07:I.CH5
C45
423322
1-W
X SP
SHLD
1-SH
62
A10
(I5)
02CBA4585
CH5DATA
C44
24
A10
(I5)
UNIT 2 DSI DUCT 1
LANCE 6
CH5DATA
C44
64
A11
(V5)
SPARE
ANALOG
INPUT
A11
(V5)
423300
1-BK
C47
REF.
4313-18
26
C:06:I.CH6
C:07:I.CH6
C47
423326
1-W
X SP
SHLD
1-SH
66
A12
(I6)
02CBA4586
CH6DATA
C45
28
A12
(I6)
UNIT 2 DSI DUCT 1
LANCE 7
CH6DATA
C45
68
A13
(V6)
SPARE
ANALOG
INPUT
A13
(V6)
423300
1-BK
C49
REF.
4313-21
30
C:06:I.CH7
1-W
SHLD
1-SH
70
A14
(I7)
02CBA4587
X SP
32
CH7DATA
C46
CH7DATA
C46
72
422603
SPARE
ANALOG
INPUT
A15
(V7)
74
C34
423300
A14
(I7)
UNIT 2 DSI DUCT 1
LANCE 8
A15
(V7)
34
C:07:I.CH7
C49
423330
C34
422603
423340
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4233
36"
12"
1
A-CP4240
36"
3
ENCLOSURE:
NEMA 4X, 304SS
36.00"H x 36.00"W x 12.00"D
BACKPANEL:
HOFFMAN A36P36
33.00"H x 33.00"W
PANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65384
2007
DRAWING NO.
9190A-7-4240
6
9
6
33"
6
8
28… "
6
7
23† "
6
8
20„ "
7
16ƒ "
10„ "
2
6† "
0"
6
5
10
0"
9
1
7
6
3•"
0
8
ALLEN-BRADLEY
1794-AENT
MODULE STATUS
5
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
6
0
5
1
9
2
8
3
7
4
0
1
2
3
6
5
4
NETWORK STATUS
LINK STATUS
7"
24
3" x 4" WIREWAY
CB
CB
CB
16
17
CB
25
21
CB
16
CB
16
CB
16
27
CB
16
CB
16
3" x 4" W I
REW AY
CB
TB2 (35) 1492-J4
CB
TB3
LNK
TX
RX
100
BaseFX
12
13
N L
1" x 4" W I
REW AY
CB
10/100
102M C
16
3" x 4" W I
REW AY
(31) 1492-J4
TB1 (2) 1492-J6,(1) 1492-JG6 &
3" x 4" W I
REW AY
22"
23
CB
18
- -
21
15
+ +
17
CB
CB
11
CB
TB3 (10) 1492-J4-B
CB
16
25
1" x 4" W I
REW AY
CB
20
CB
BaseTX
TB2
14
SOLA
POW ER SUPPLY
SDN 2.5-24-100P
TB1
19
ACT
25
CB
CB
CB
16
17
CB
CB
26
22
1" x 4" WIREWAY
29
CLEAR AREA
30
28
4
ELECTRIC HEATER
3" x 4" WIREWAY
33"
ENCLOSURE:
NEMA 4X, 304SS
36.00"H x 36.00"W x 12.00"D
BACKPANEL:
HOFFMAN A36P36
33.00"H x 33.00"W
BACKPANEL LAYOUT
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
3/8"=1"
c
CATALOG NO.
65384
2007
DRAWING NO.
9190A-7-4241
ITEM
QTY.
DESCRIPTION
1
1
ENCLOSURE, NEMA 4X, 36" X 36" X 12", 304SS SINGLE DOOR
HOFFMAN
MANUFACTURER
A-36H3612SSLP
PART No.
2
1
BACK PANEL, 33.00" X 33.00"
HOFFMAN
A-36P36
3
1
PER PRINT/LIST
LEGEND
4
1
HOFFMAN
DAH2001A
5
1
FLEX I/O ETHERNET ADAPTER MODULE W/24VDC POWER SUPPLY
ALLEN-BRADLEY
1794-AENT
6
8
FLEX I/O TERMINAL WIRING BASE
ALLEN-BRADLEY
1794-TB3
7
2
FLEX I/O 16-POINT, 120 VAC, INPUT MODULE
ALLEN-BRADLEY
1794-IA16
8
3
FLEX I/O, ISOLATED OUTPUT MODULE, 120 VAC, 8 POINT
ALLEN-BRADLEY
1794-OA8I
9
1
FLEX I/O, 16-POINT, 120VAC, OUTPUT MODULE
ALLEN-BRADLEY
1794-OA16
10
2
FLEX I/O, INPUT MODULE, ANALOG, 24 VDC, 8 SINGLE ENDED INPUTS
ALLEN-BRADLEY
1794-IE8
11
1
CONVERTER, MEDIA, (1)10/100 COPPER TO (1) FIBER, ST CONNECTOR, 24 VDC
N-TRON
102MC-ST
12
1
BELDEN
5FTCAT5EPATCH
13
1
SOLA
SDN 2.5-24-100P
14
1
ALLEN-BRADLEY
1489-M1C200
15
1
ALLEN-BRADLEY
1489-M1C050
16
10
ALLEN-BRADLEY
1489-M1C030
17
13
ALLEN-BRADLEY
1489-M1C020
18
1
ALLEN-BRADLEY
1489-M1C010
19
2
ALLEN-BRADLEY
1492-J6
20
1
ALLEN-BRADLEY
1492-JG6
21
67
ALLEN-BRADLEY
1492-J4
22
10
ALLEN-BRADLEY
1492-J4-B
23
1
ALLEN-BRADLEY
1492-CJJ6-10
24
8
ALLEN-BRADLEY
1492-EAJ35
25
11
ALLEN-BRADLEY
1492-EBJ3
26
2
ALLEN-BRADLEY
1492-EBJ3-B
27
2
GROUND BAR, 7 POINT
SQUARE D
PK7GTA
28
110"
PHOENIX CONTACT
CD-HF 80X100 3240360
29
40"
PHOENIX CONTACT
CD-HF 30X100 3240347
30
90"
DIN RAIL
ALLEN-BRADLEY
199-DR1
BILL OF MATERIAL
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65384
2007
DRAWING NO.
9190A-7-4242
TB1
TB2
TB3
H403609
No. Qty.
1
1
LINE #1
LINE #2
LEGEND SIZE
LETTER SIZE
TAG COLOR
TEXT COLOR
A-CP4240
.
ƒ" x 4•"
•"
WHITE
BLACK
424516
1
1
2
2
424604
GND
424640
3
3
424502
425014
424504
425016
424540
425055
4
6
425000
5
5
6
6
425054
AMP
2
AMP
425340
TB1-6
5
AMP
424603
7
7
TB1-7
8
8
TB1-8 - TB1-13
2
AMP
9
9
TB1-24
3
AMP
10
10
TB1-32
3
AMP
7
424540
20
TB1-5
4
424640
5
424600
TB1-4
425300
3
424642
4
424502
CB & FUSE CHART
424606
2
425000
H403609
A-CP4240
424604
1
N403609
1
424602
425056
8
425040
424518
9
425100
10
425140
425000
425200
425018
11
11
12
425240
12
TB1-40
3
AMP
13
13
TB2-1
3
AMP
14
14
TB2-9
3
AMP
15
15
TB2-17
3
AMP
425103
14
425102
15
AMP
12
425020
13
N403609
11
424604
1
425104
16
16
17
17
16
TB2-25
3
AMP
18
TB2-33
3
AMP
19
TB3-1
3
AMP
TB3-2
3
AMP
22
TB3-3
2
AMP
23
TB3-4
2
AMP
TB3-5 - TB3-6
2
AMP
424520
18
424502
425000
19
425022
20
20
425024
21
21
425107
22
425106
23
424510
425108
24
24
424522
25
25
26
26
425000
425002
425000
27
27
425004
425026
28
28
425043
425028
29
JOB #9190A
29
425042
425111
30
30
425044
120/1/60
425110
31
31
424512
425112
32
32
424524
33
33
34
34
425000
425006
425000
35
35
425008
425030
36
36
425047
425032
37
37
425046
HOLES IN ENCLOSURE
425115
38
38
425048
425114
39
424514
40
39
MUST BE FILLED WITH
40
425116
41
425000
42
425010
43
425012
44
425051
45
425050
46
425052
47
COPPER WIRE WITH
48
60 DEG C INSULATION
TERMINAL BLOCK
TIGHTENING TORQUE
1492-J4 - 9.0 LB-IN
1492-J6 - 14.2 LB-IN
1492-H... - 7.1 LB-IN
U
L
R
Underwriters
Laboratories Inc.
R
LISTED
No. AA-______
TB1
TB2
TB3
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN
DESIGN
OWENSBORO, KY
DRAWN BY
DESIGN BY
J. ATKINSON
A. HEUER
DATE
SCALE
10.Feb.15
NONE
c
CATALOG NO.
65384
2007
DRAWING NO.
9190A-7-4243
424502
N403609
WIRING LEGEND
- DENOTES PRE-WIRED
CB-424540
GND
REF.
4036-09
00
424502
40
02CBD4099
3-BL
TB1-3
0 SP
424540
5A
TB1-6
POWER FOR
DIGITAL INPUT &
OUTPUT CARDS
N403609
TB1-14
120VDC POWER
TO DIGITAL
INPUTS & OUTPUTS
CB-424502
424502
02
H403609
20A
TB1-4
TB1-1
H403609
N403609
1-BK
2-R
N403609
42
TB1-2
CB-424504
424502
04
424504
2A
TB1-5
N403609
H
HEATER
N403609
N
TB1-14
120VAC POWER TO
ENCLOSURE
HEATER
44
06
46
08
48
CB-424510
424502
10
3A
TB1-24
CB-424512
424516
N403609
1-BK
2-R
424518
N403609
1-BK
2-R
TB2-2
424520
N403609
1-BK
2-R
TB2-10
424522
N403609
1-BK
2-R
TB2-18
TB2-26
REF.
4250-29
424524
N403609
1-BK
2-R
N403609
TB2-34
02CBD4085
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 4 MOV
56
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 5 MOV
58
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 6 MOV
60
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 7 MOV
62
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 8 MOV
64
REF.
4315-19
X SP
3A
TB2-33
54
REF.
4315-10
N403609
02CBD4084
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 3 MOV
REF.
4315-00
N403609
02CBD4083
52
REF.
4314-29
N403609
02CBD4082
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 2 MOV
REF.
4314-19
N403609
02CBD4081
REF.
4250-25
424502
24
TB1-41
X SP
3A
TB2-25
CB-424524
N403609
02CBD4080
REF.
4250-21
424502
22
2-R
X SP
3A
TB2-17
CB-424522
N403609
1-BK
REF.
4250-17
424502
20
424514
50
REF.
4314-10
X SP
3A
TB2-9
CB-424520
N403609
TB1-33
02CBD4079
REF.
4250-13
424502
18
2-R
X SP
3A
TB2-1
CB-424518
1-BK
REF.
4250-09
424502
16
N403609
120VAC POWER TO
UNIT 2 DSI DUCT 2
LANCE 1 MOV
REF.
4314-00
X SP
3A
TB1-40
CB-424516
N403609
TB1-25
02CBD4078
424512
REF.
4250-05
424502
14
2-R
X SP
3A
TB1-32
CB-424514
N403609
1-BK
REF.
4250-01
424502
12
424510
REF.
4315-29
X SP
26
66
28
68
30
70
32
72
34
74
424502
N403609
424502
N403609
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4245
424544
N403609
424604
424603
WIRING LEGEND
- DENOTES PRE-WIRED
CB-424600
424544
00
CB-424640
424600
N403609
424604
40
1A
TB1-7
POWER FOR
ANALOG INPUT &
OUTPUT CARDS
424640
2A
TB3-3
424603
TB3-8
24VDC POWER
FOR ANALOG
INPUTS & OUTPUTS
L N G
CB-424642
SOLA/HEVI DUTY
24VDC POWER
SUPPLY
POWER SUPPLY
24 VDC
2.5 AMP
02
424642
2A
TB3-4
H
ALLEN-BRADLEY
1794-AENT
424603
N
TB3-8
G
ALLEN-BRADLEY
1794-AENT
ETHERNET MODULE
+ -
CB-424604
424604
04
424604
42
424602
424603
44
3A
TB3-1
TB3-7
CB-424606
424604
06
413606
3A
TB3-2
+
NTRON
MEDIA
CONVERTER
424603
G
TB3-7
N-TRON
MEDIA
CONVERTER
46
08
48
10
50
12
52
14
54
16
56
18
58
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
424604
424603
424604
424603
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4246
424540
N403609
424540
N403609
REF.
4245-11
C35
425000
02
TB1-26
40
UNIT 2 DSI DUCT 2
LANCE 1 MOV
CLOSED LIMIT SWITCH
42
REF.
4250-42
425000
425002
4-O
5-Y
425002
TB1-27
D:00:I.00
A0
DATA[0].00
2A
TB1-9
B16
RACK D, MODULE 0
CB-425040
1794-IA16/
1794-TB3
2A
TB1-8
00
CB-425000
WIRING LEGEND
- DENOTES PRE-WIRED
1794-OA8I/
B16
D:01:O.00
425042
425042
TB1-30
8-BL/BK
425043
425043
TB1-29
425044
425044
TB1-31
9-O/BK
UNIT 2 DSI DUCT 2
LANCE 1 MOV
OPEN COMMAND
REF.
4250-01
A0
DATA[1].00
1794-TB3 120VAC ISO. OUTPUT
RACK D, MODULE 1
1794-TB3
A1
C36
425004
04
6-BR
REF.
4245-13
C37
425000
06
TB1-34
425004
TB1-28
D:00:I.01
A1
DATA[0].01
UNIT 2 DSI DUCT 2
LANCE 1 MOV
OPEN LIMIT SWITCH
D:00:I.02
A2
DATA[0].02
UNIT 2 DSI DUCT 2
LANCE 2 MOV
CLOSED LIMIT SWITCH
D:01:O.01
44
DATA[1].01
REF.
4250-46
425000
425006
4-O
5-Y
7-R/BK
UNIT 2 DSI DUCT 2
LANCE 1 MOV
CLOSE COMMAND
A2
A3
425006
TB1-35
D:01:O.02
46
425046
425046
TB1-38
425047
UNIT 2 DSI DUCT 2
LANCE 2 MOV
OPEN COMMAND
REF.
4250-05
A4
DATA[1].02
8-BL/BK
425047
A5
C38
425008
08
6-BR
REF.
4245-15
C39
425000
10
TB1-42
425008
TB1-36
D:00:I.03
A3
DATA[0].03
UNIT 2 DSI DUCT 2
LANCE 2 MOV
OPEN LIMIT SWITCH
D:00:I.04
A4
DATA[0].04
UNIT 2 DSI DUCT 2
LANCE 3 MOV
CLOSED LIMIT SWITCH
D:01:O.03
48
425010
4-O
5-Y
425048
TB1-39
9-O/BK
UNIT 2 DSI DUCT 2
LANCE 2 MOV
CLOSE COMMAND
A6
DATA[1].03
REF.
4250-50
425000
7-R/BK
TB1-37
425048
A7
425010
TB1-43
D:01:O.04
50
425050
425050
TB1-46
425051
UNIT 2 DSI DUCT 2
LANCE 3 MOV
OPEN COMMAND
REF.
4250-09
A8
DATA[1].04
8-BL/BK
425051
A9
C40
425012
12
6-BR
REF.
4245-17
C41
425000
14
TB2-3
425012
TB1-44
D:00:I.05
A5
DATA[0].05
UNIT 2 DSI DUCT 2
LANCE 3 MOV
OPEN LIMIT SWITCH
D:00:I.06
A6
DATA[0].06
UNIT 2 DSI DUCT 2
LANCE 4 MOV
CLOSED LIMIT SWITCH
D:01:O.05
52
425014
4-O
5-Y
7-R/BK
UNIT 2 DSI DUCT 2
LANCE 3 MOV
CLOSE COMMAND
425052
A10
DATA[1].05
REF.
4250-54
425000
TB1-45
425052
TB1-47
9-O/BK
A11
425014
TB2-4
D:01:O.06
54
425054
425054
TB2-7
425055
8-BL/BK
DATA[1].06
UNIT 2 DSI DUCT 2
LANCE 4 MOV
OPEN COMMAND
REF.
4250-13
A12
425055
A13
C42
425016
16
6-BR
REF.
4245-19
C43
425000
18
TB2-11
425018
4-O
5-Y
6-BR
REF.
4245-21
425000
22
TB2-19
425022
4-O
5-Y
C46
REF.
4245-23
425000
26
TB2-27
425026
4-O
5-Y
C48
6-BR
425000
30
TB2-35
C50
32
DATA[1].07
TB2-13
D:00:I.08
A8
DATA[0].08
UNIT 2 DSI DUCT 2
LANCE 5 MOV
CLOSED LIMIT SWITCH
58
D:00:I.09
A9
DATA[0].09
UNIT 2 DSI DUCT 2
LANCE 5 MOV
OPEN LIMIT SWITCH
60
425022
D:00:I.10
A10
DATA[0].10
UNIT 2 DSI DUCT 2
LANCE 6 MOV
CLOSED LIMIT SWITCH
TB2-20
62
425024
D:00:I.11
A11
DATA[0].11
UNIT 2 DSI DUCT 2
LANCE 6 MOV
OPEN LIMIT SWITCH
TB2-21
64
425026
D:00:I.12
A12
DATA[0].12
UNIT 2 DSI DUCT 2
LANCE 7 MOV
CLOSED LIMIT SWITCH
TB2-28
66
425028
D:00:I.13
A13
DATA[0].13
UNIT 2 DSI DUCT 2
LANCE 7 MOV
OPEN LIMIT SWITCH
TB2-29
68
425000
425030
4-O
5-Y
425032
425030
TB2-36
D:00:I.14
A14
DATA[0].14
UNIT 2 DSI DUCT 2
LANCE 8 MOV
CLOSED LIMIT SWITCH
70
425032
TB2-37
D:00:I.15
A15
DATA[0].15
UNIT 2 DSI DUCT 2
LANCE 8 MOV
OPEN LIMIT SWITCH
72
UNIT 2 DSI DUCT 2
LANCE 4 MOV
CLOSE COMMAND
C34
74
C34
425000
TB2-8
9-O/BK
REF.
4251-14
6-BR
34
425020
425028
REF.
4245-25
7-R/BK
425056
A14
REF.
4251-10
425000
28
C49
TB2-12
425024
6-BR
C47
56
TB2-6
425056
REF.
4251-06
425000
24
D:01:O.07
A15
425018
425020
20
C45
TB2-5
UNIT 2 DSI DUCT 2
LANCE 4 MOV
OPEN LIMIT SWITCH
REF.
4251-02
425000
C44
425016
D:00:I.07
A7
DATA[0].07
N403609
N403609
425040
I/O WIRING DIAGRAM, RACK D SLOTS 0 & 1
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4250
424540
N403609
424540
N403609
RACK D, MODULE 2
1794-TB3
B16
D:02:O.00
02
425102
425102
A0
DATA[2].00
TB2-15
8-BL/BK
425103
425103
TB2-14
425104
7-R/BK
TB2-16
9-O/BK
REF.
4250-17
UNIT 2 DSI DUCT 2
LANCE 5 MOV
OPEN COMMAND
42
UNIT 2 DSI DUCT 2
LANCE 5 MOV
CLOSE COMMAND
44
UNIT 2 DSI DUCT 2
LANCE 6 MOV
OPEN COMMAND
46
UNIT 2 DSI DUCT 2
LANCE 6 MOV
CLOSE COMMAND
48
UNIT 2 DSI DUCT 2
LANCE 7 MOV
OPEN COMMAND
50
UNIT 2 DSI DUCT 2
LANCE 7 MOV
CLOSE COMMAND
52
UNIT 2 DSI DUCT 2
LANCE 8 MOV
OPEN COMMAND
54
UNIT 2 DSI DUCT 2
LANCE 8 MOV
CLOSE COMMAND
56
1794-IA16/
1794-TB3
2A
TB1-11
1794-OA8I/
CB-425140
2A
TB1-10
00
CB-425120
WIRING LEGEND
- DENOTES PRE-WIRED
B16
RACK D, MODULE 3
C35
D:03:I.00
A0
DATA[3].00
SPARE
INPUT
C36
D:03:I.01
A1
DATA[3].01
SPARE
INPUT
C37
D:03:I.02
A2
DATA[3].02
SPARE
INPUT
C38
D:03:I.03
A3
DATA[3].03
SPARE
INPUT
C39
D:03:I.04
A4
DATA[3].04
SPARE
INPUT
C40
D:03:I.05
A5
DATA[3].05
A1
D:02:O.01
04
425104
A2
DATA[2].01
A3
D:02:O.02
06
425106
425106
A4
DATA[2].02
TB2-23
425107
8-BL/BK
REF.
4250-21
425107
A5
D:02:O.03
08
TB2-22
425108
7-R/BK
425108
A6
DATA[2].03
TB2-24
9-O/BK
A7
D:02:O.04
10
425110
425110
A8
DATA[2].04
TB2-31
425111
8-BL/BK
REF.
4250-25
425111
A9
D:02:O.05
12
TB2-30
425112
7-R/BK
425112
A10
DATA[2].05
TB2-32
9-O/BK
SPARE
INPUT
A11
D:02:O.06
14
425114
425114
A12
DATA[2].06
TB2-39
425115
8-BL/BK
TB2-38
425116
7-R/BK
TB2-40
9-O/BK
REF.
4250-29
C41
D:03:I.06
A6
DATA[3].06
SPARE
INPUT
C42
D:03:I.07
A7
DATA[3].07
SPARE
INPUT
C43
D:03:I.08
A8
DATA[3].08
SPARE
INPUT
C44
D:03:I.09
A9
DATA[3].09
SPARE
INPUT
C45
D:03:I.10
A10
DATA[3].10
SPARE
INPUT
C46
D:03:I.11
A11
DATA[3].11
SPARE
INPUT
C47
D:03:I.12
A12
DATA[3].12
SPARE
INPUT
C48
D:03:I.13
A13
DATA[3].13
SPARE
INPUT
C49
D:03:I.14
A14
DATA[3].14
SPARE
INPUT
C50
D:03:I.15
A15
DATA[3].15
SPARE
INPUT
425115
A13
D:02:O.07
16
425116
A14
DATA[2].07
A15
18
58
C34
20
60
22
62
24
64
26
66
28
68
30
70
32
72
34
74
425120
N403609
C34
N403609
425140
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4251
424540
N403609
424540
N403609
1794-TB3
B16
D:04:O.00
02
A0
DATA[4].00
RACK D, MODULE 4
SPARE
OUTPUT
2A
TB1-13
1794-OA8I/
CB-425240
2A
TB1-12
00
CB-425200
WIRING LEGEND
- DENOTES PRE-WIRED
1794-OA16/
B16
D:05:O.00
42
425242
N403609
1-BK
2-R
A1
D:04:O.01
04
A2
DATA[4].01
02CBD4408
SPARE
OUTPUT
D:04:O.02
A4
DATA[4].02
D:05:O.01
44
425244
N403609
1-BK
2-R
D:04:O.03
A6
DATA[4].03
D:05:O.02
46
425246
N403609
1-BK
2-R
D:04:O.04
A8
DATA[4].04
D:05:O.03
48
425248
N403609
1-BK
2-R
D:04:O.05
A10
DATA[4].05
D:05:O.04
50
425250
N403609
1-BK
2-R
14
A12
D:05:O.05
52
425252
N403609
1-BK
2-R
DATA[4].06
D:05:O.06
16
A14
54
425254
N403609
1-BK
2-R
DATA[4].07
DATA[5].06
D:05:O.07
56
425256
N403609
1-BK
2-R
B24
PURGE SOLENOID
A7
DATA[5].07
02CBD4415
D:05:O.08
58
C34
PURGE SOLENOID
REF.
4316-20
X SP
A15
18
B23
A6
02CBD4414
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-16
X SP
A13
D:04:O.07
B22
A5
DATA[5].05
02CBD4413
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-13
X SP
A11
D:04:O.06
B21
A4
DATA[5].04
02CBD4412
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-10
X SP
A9
12
B20
A3
DATA[5].03
02CBD4411
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-06
X SP
A7
10
B19
A2
DATA[5].02
02CBD4410
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-03
X SP
A5
08
B18
A1
DATA[5].01
02CBD4409
SPARE
OUTPUT
PURGE SOLENOID
REF.
4316-23
X SP
B25
A8
DATA[5].08
B26
D:05:O.09
20
60
A9
DATA[5].09
B27
D:05:O.10
22
62
A10
DATA[5].10
B28
D:05:O.11
24
64
A11
DATA[5].11
B29
D:05:O.12
26
66
A12
DATA[5].12
B30
D:05:O.13
28
68
A13
DATA[5].13
B31
D:05:O.14
30
70
A14
DATA[5].14
B32
D:05:O.15
32
72
A15
DATA[5].15
34
74
425200
N403609
REF.
4316-00
X SP
A3
06
B17
A0
DATA[5].00
ALLEN-BRADLEY 1794-OA16/
1794-TB3 120VAC OUTPUT
RACK D, MODULE 5
1794-TB3
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
SPARE
OUTPUT
C34
N403609
425240
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4252
424640
424603
424640
424603
40
425300
1-BK
C35
REF.
4317-00
02
D:06:I.CH0
1794-IE8/
1794-TB3
2A
TB3-6
B16
RACK D, MODULE 6
CB-425340
1794-IE8/
1794-TB3
2A
TB3-5
00
CB-425300
WIRING LEGEND
- DENOTES PRE-WIRED
B16
RACK D, MODULE 7
D:07:I.CH0
C35
425302
1-W
X SP
SHLD
1-SH
42
A0
(I0)
02CBA4588
CH0DATA
C39
04
A0
(I0)
UNIT 2 DSI DUCT 2
LANCE 1
CH0DATA
C39
44
A1
(V0)
SPARE
ANALOG
INPUT
A1
(V0)
425300
1-BK
C37
REF.
4317-03
06
D:06:I.CH1
D:07:I.CH1
C37
425306
1-W
X SP
SHLD
1-SH
46
A2
(I1)
02CBA4589
CH1DATA
C40
08
A2
(I1)
UNIT 2 DSI DUCT 2
LANCE 2
CH1DATA
C40
48
A3
(V1)
SPARE
ANALOG
INPUT
A3
(V1)
425300
1-BK
C39
REF.
4317-06
10
D:06:I.CH2
D:07:I.CH2
C39
425310
1-W
X SP
SHLD
1-SH
50
A4
(I2)
02CBA4590
CH2DATA
C41
12
A4
(I2)
UNIT 2 DSI DUCT 2
LANCE 3
CH2DATA
C41
52
A5
(V2)
SPARE
ANALOG
INPUT
A5
(V2)
425300
1-BK
C41
REF.
4317-09
14
D:06:I.CH3
D:07:I.CH3
C41
425314
1-W
X SP
SHLD
1-SH
54
A6
(I3)
02CBA4591
CH3DATA
C42
16
A6
(I3)
UNIT 2 DSI DUCT 2
LANCE 4
CH3DATA
C42
56
A7
(V3)
SPARE
ANALOG
INPUT
A7
(V3)
425300
1-BK
C43
REF.
4317-12
18
D:06:I.CH4
D:07:I.CH4
C43
425318
1-W
X SP
SHLD
1-SH
58
A8
(I4)
02CBA4592
CH4DATA
C43
20
A8
(I4)
UNIT 2 DSI DUCT 2
LANCE 5
CH4DATA
C43
60
A9
(V4)
SPARE
ANALOG
INPUT
A9
(V4)
425300
1-BK
C45
REF.
4317-15
22
D:06:I.CH5
D:07:I.CH5
C45
425322
1-W
X SP
SHLD
1-SH
62
A10
(I5)
02CBA4593
CH5DATA
C44
24
A10
(I5)
UNIT 2 DSI DUCT 2
LANCE 6
CH5DATA
C44
64
A11
(V5)
SPARE
ANALOG
INPUT
A11
(V5)
425300
1-BK
C47
REF.
4317-18
26
D:06:I.CH6
D:07:I.CH6
C47
425326
1-W
X SP
SHLD
1-SH
66
A12
(I6)
02CBA4594
CH6DATA
C45
28
A12
(I6)
UNIT 2 DSI DUCT 2
LANCE 7
CH6DATA
C45
68
A13
(V6)
SPARE
ANALOG
INPUT
A13
(V6)
425300
1-BK
C49
REF.
4317-21
30
D:06:I.CH7
1-W
SHLD
1-SH
70
A14
(I7)
02CBA4595
X SP
32
CH7DATA
C46
CH7DATA
C46
72
424603
SPARE
ANALOG
INPUT
A15
(V7)
74
C34
425300
A14
(I7)
UNIT 2 DSI DUCT 2
LANCE 8
A15
(V7)
34
D:07:I.CH7
C49
425330
C34
424603
425340
1
26AUG15
0
01JUN15
REV
DATE
PANEL AS BUILT
REVISION NOTE
JPN
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4253
WIRING LEGEND
UNIT 2
A
AIR COMPRESSOR 1
- DENOTES PRE-WIRED
E
00
REF.
4021-06
1-BK (BR)402106
L1
L2
L3
PE
02CBG4004
2-BK (O) 402107
0 SP
3-BK (Y) 402108
BARE
GND
1-BK
414200
4
5-Y
414204
2
7-R/BK 414208
3
3
02
REF.
02CBD4216
4142-01
RL1
"ALARM"
X SP
RL2
"ALERT"
4
04
2
4-O
414202
06
6-BR
3
7
8
9
RL3
"RUNNING"
4
2
414206
3
RL4
"LOADED"
4
2
08
UNIT 2
B
AIR COMPRESSOR 2 DRYER
REF.
4036-16
0 SP
REF.
4142-09
H403616
3-BL
GND
2-R
N403616
1-BK
414200
2-R
414210
TB-1
1
2
3
14
15
02CBD4216
X SP
ALARM
A
CONTROL
PANEL
UNIT 2 DRY AIR SURGE TANK 1
C
14
C
1-BK
414900
1-W
414908
1-SH
SHLD
02CBA4517
UNIT 2 ELECTRICAL BUILDING
18
REF.
4021-18
1-BK (BR)402118
02CBG4007
2-BK (O) 402119
0 SP
3-BK (Y) 402120
GND
L1
L2
L3
GND
B
20
E
EXHAUST FAN 1 MOTOR
22
AF
PF
2
BARE
D
CONTROL
PANEL
HVAC
1
16
2
AF
0 SP
1
1
REF.
4149-08
2
12
1-BK
02CBD4117
PF
10
REF.
4135-25
1-BK
1
413524
LOUVER 1
02CBD4212
H
?HP
0 SP
2-R
N404100
3-BL
GND
MTR
REF.
4135-29
0 SP
1-BK
413528
2-R
N40410
3-BL
GND
L1
L2
GND
24
EXHAUST FAN 2 MOTOR
F
26
REF.
4135-27
1-BK
413526
LOUVER 2
02CBD4213
J
?HP
0 SP
2-R
N404100
3-BL
GND
MTR
REF.
4135-31
0 SP
1-BK
413530
2-R
N40410
3-BL
GND
L1
L2
GND
28
G
EXHAUST THERMOSTAT
30
REF.
4142-15
1-BK
414200
414216
2-R
02CBD4211
X SP
D
32
AMBIENT TEMPERATURE
CONTROLS BUILDING
REF.
4076-30
34
1-BK
407602
407632
N
THERMOSTAT
PLAN VIEW
2-R
X SP
(FIELD LOCATE)
36
MECHANICAL/ELECTRICAL BUILDING
FIELD WIRING DIAGRAM
1
26AUG15
0
01JUN15
REV
DATE
ADDED LOUVERS
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4300
WIRING LEGEND
UNIT 2 DSI LINE 1
A
BLOWER MOTOR
- DENOTES PRE-WIRED
REF.
4115-06
1-BK (BR)411506
02CBG4022
2-BK (O) 411507
0 SP
3-BK (Y) 411508
02
REF.
4118-07
BARE
GND
1-BK
411531
2-R
NEUTRA
02CBD4111
50HP
MTR
HEATER
00
L
N
0 SP
A
B
C
D
E
F
G
H
J
UNIT 2 DSI LINE 1
04
B
BLOWER PRESS. TRANS.
REF.
4148-16
1-BK
414800
1-W
414816
1-SH
SHLD
02CBA4507
0 SP
1
2
06
UNIT 2 DSI LINE 1
C
BLOWER TEMP. TRANS.
REF.
4148-22
0 SP
414800
1-W
414822
1-SH
SHLD
1
2
UNIT 2 DSI
10
LINE 2
D
BLOWER MOTOR
REF.
4125-06
1-BK (BR)412506
02CBG4025
2-BK (O) 412507
0 SP
12
3-BK (Y) 412508
REF.
4128-07
BARE
GND
1-BK
412531
2-R
NEUTRA
02CBD4113
50HP
MTR
L
N
0 SP
UNIT 2 DSI
CONTROL
PANEL
14
1-BK
02CBA4508
HEATER
08
LINE 2
E
16
1-BK
414840
1-W
414856
1-SH
SHLD
02CBA4513
LINE 2
0 SP
SHLD
1
2
AF
414862
1-SH
2
414840
1-W
2
1-BK
02CBA4514
PF
REF.
4148-62
20
1
F
PF
UNIT 2 DSI
BLOWER TEMP. TRANS.
1
18
1
2
AF
0 SP
CONTROL
PANEL
REF.
4148-56
UNIT 2 TRUCK UNLOAD
G
BLOWER MOTOR
22
1-BK (BR)410506
02CBG4020
2-BK (O) 410507
0 SP
3-BK (Y) 410508
24
REF.
4106-05
BARE
GND
1-BK
410513
2-R
NEUTRA
02CBD4115
60HP
MTR
HEATER
REF.
4105-06
L
N
0 SP
26
UNIT 2 TRUCK UNLOAD
28
REF.
4147-56
1-BK
414740
1-W
414756
1-SH
SHLD
02CBA4501
0 SP
H
1
2
UNIT 2 TRUCK UNLOAD
BLOWER TEMP. TRANS.
30
REF.
4147-62
1-BK
414740
1-W
414762
1-SH
SHLD
02CBA4502
0 SP
J
1
2
CONTROLS BUILDING
N
32
PLAN VIEW
34
36
BLOWERS
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4301
WIRING LEGEND
UNIT 2 DSI LINE 1
BLOWER HEAT EXCH. MOTOR
A
- DENOTES PRE-WIRED
00
REF.
4116-06
1-BK (BR)411606
02CBG4023
2-BK (O) 411607
0 SP
3-BK (Y) 411608
BARE
2HP
MTR
GND
02
UNIT 2 DSI LINE 1
BLOWER H.E. TEMP. TRANS.
04
REF.
4148-28
1-BK
414800
1-W
414828
1-SH
SHLD
02CBA4509
0 SP
1
2
UNIT 2 DSI
06
2-BK (O) 412607
3-BK (Y) 412608
BARE
10
D
2HP
MTR
GND
UNIT 2 DSI
LINE 2
REF.
4148-68
C
1-BK (BR)412606
0 SP
1-BK
414840
1-W
414868
1-SH
SHLD
02CBA4515
0 SP
12
B
C
02CBG4026
4126-06
08
A
LINE 2
REF.
B
D
G
H
J
K
1
2
E
F
UNIT 2 TRUCK UNLOAD
E
14
REF.
4105-20
1-BK (BR)410520
02CBG4021
2-BK (O) 410521
3-BK (Y) 410522
BARE
16
2HP
CONTROL
PANEL
0 SP
MTR
GND
UNIT 2 TRUCK UNLOAD
F
18
1-BK
414740
1-W
414768
1-SH
SHLD
02CBA4503
0 SP
1
UNIT 2 DSI SILO TRUCK UNLOAD
2
G
DEHUMIDIFIER
20
CC
(C1)
1A
1A
H
F4
UNIT 2 TRUCK UNLOAD DEHUMIDIFIER
EVAPORATOR INLET AIR TEMPERATURE SWITCH
1-BK
414200
414212
15A
FM1
F2
15A
H1 460
REF.
4142-11
1
COMP.
3
F1
GND
F3
BARE
AF
T3
3-BK (Y) 402117
22
2
L3
2
PF
T2
AF
T1
L2
2-BK (O) 402116
0 SP
1
1
L1
2
1-BK (BR)402115
02CBG4014
PF
REF.
4021-15
24
CONTROL
PANEL
REF.
4147-68
H4
2-R
02CBD4217
X4
X1
240
X SP
T1
T2
YELLOW
BLUE
IN LINE
26
EVAPORATOR OUTLET AIR TEMPERATURE SWITCH
LIQUID SOLENOID
R1
CCH
UNIT 2 TRUCK UNLOAD DEHUMIDIFIER
J
4
5
1-BK
2-R
3-BL
1-BK
414200
414214
0 SP
2-R
02CBD4218
PDS
X SP
28
R1
C1
REF.
4142-13
LLS
L2
CMOD
AUX2
1
2
AUX1
SHLD
DPS
414928
1-SH
DT
414900
1-W
HPS
0 SP
LPS
1-BK
02CBA4519
K
TDR
REF.
4149-28
L1
EVAP. DIFF. PRESS. TRANS.
30
COMP
SERVICE MATE
32
DPC
34
M1
DPS
240M
REF.
4144-47
1-BK
414448
2-R
N404100
CONTROLS BUILDING
L2
PLAN VIEW
02CBD4205
X SP
N
LINE
RUN COMMAND
36
BLOWER HEAT EXCHANGERS
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4302
WIRING LEGEND
UNIT 2 DSI
SILO
A
JIB CRANE
A
- DENOTES PRE-WIRED
00
REF.
4021-61
1-BK (BR)402161
L1
L2
L3
GND
02CBG4005
2-BK (O) 402162
0 SP
3-BK (Y) 402163
BARE
GND
02
UNIT 2 DSI
SILO
B
EMERGENCY HIGH LEVEL PROBE
REF.
04
1-BK
414300
2-R
N404100
02CBD4299
4176-00
X SP
1
L1
120
2
L2
VAC
3
4
*
3-BL
414314
5
6
06
7
8
4-O
1 2 3 NO
GND
ON
08
NC
JUMPER
UNIT 2 DSI
SILO
C
HIGH LEVEL PROBE
10
REF.
4176-04
KEY
ON
OFF
* FIELD INSTALLED
1-BK
414300
2-R
N404100
02CBD4302
X SP
1
L1
120
2
L2
VAC
3
4
*
3-BL
414316
5
12
6
7
D
8
4-O
1 2 3 NO
GND
ON
14
OFF
* FIELD INSTALLED
NC
JUMPER
UNIT 2 DSI
SILO
D
MID LEVEL PROBE
16
REF.
4176-08
KEY
ON
1-BK
414300
2-R
N404100
02CBD4303
X SP
B
1
L1
120
2
L2
VAC
3
C
4
*
18
3-BL
414318
5
6
7
G
8
4-O
20
1 2 3 NO
GND
ON
KEY
F
ON
OFF
* FIELD INSTALLED
NC
JUMPER
UNIT 2 DSI SILO TRUCK FILL
LINE CONNECTED LIMIT SWITCH
E
22
REF.
4165-53
1-BK
414340
414352
2-R
02CBD4300
X SP
24
N
UNIT 2 DSI
SILO
CONTINUOUS LEVEL TRANS. 1
26
REF.
4178-00
1-BK
414740
1-W
414744
1-SH
SHLD
1
2
UNIT 2 DSI
28
SILO
CONTINUOUS LEVEL TRANS. 2
REF.
4178-04
1-BK
414740
1-W
414748
1-SH
SHLD
02CBA4559
0 SP
SILO TOP
PLAN VIEW
02CBA4558
0 SP
F
G
1
2
30
E
UNIT 2
WELDING RECEPTACLE
32
REF.
4021-12
1-BK (BR)402112
02CBG4010
2-BK (O) 402113
0 SP
3-BK (Y) 402114
BARE
34
GND
H
L1
L2
L3
GND
SILO ELEVATION
36
SILO EXTERIOR
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4303
WIRING LEGEND
UNIT 2 DSI
SILO
A
HEATER
- DENOTES PRE-WIRED
00
REF.
4021-58
1-BK (BR)402158
L1
L2
L3
GND
02CBG4006
2-BK (O) 402159
0 SP
3-BK (Y) 402160
BARE
GND
02
UNIT 2 DSI
SILO
B
PANT LEG 1 LOW LEVEL PROBE
REF.
04
1-BK
414340
2-R
N404100
02CBD4308
4195-00
X SP
1
L1
120
2
L2
VAC
3
4
*
4-O
414354
5
6
06
7
8
3-BL
1 2 3 NO
GND
ON
08
NC
JUMPER
UNIT 2 DSI
SILO
C
PANT LEG 2 LOW LEVEL PROBE
10
REF.
4195-04
KEY
ON
OFF
* FIELD INSTALLED
1-BK
414340
2-R
N404100
02CBD4309
X SP
1
L1
120
2
L2
VAC
3
4-O
H
4
*
414356
5
12
B
C
6
7
8
3-BL
1 2 3 NO
GND
ON
14
KEY
ON
OFF
* FIELD INSTALLED
NC
JUMPER
UNIT 2 DSI
SILO
D
16
REF.
4195-08
1-BK
414340
02CBD4310
X SP
1
*
NO
2
4-O
C
414358
3
CLOSED LS
(SHOWN CLOSED)
NC
A
4
NO
5
18
5-Y
414360
2-R
N404100
6-BR
414516
6
C
NC
OPEN LS
F
7
G
OPEN SOL
8
3-BL
* FIELD INSTALLED
GND
G
D
E
JUMPER
20
UNIT 2 DSI
SILO
E
REF.
4195-16
22
1-BK
414340
4-O
414362
02CBD4311
X SP
1
*
NO
2
3
C
CLOSED LS
(SHOWN CLOSED)
NC
4
NO
5
5-Y
414364
2-R
N404100
6
C
NC
7
24
6-BR
414518
3-BL
GND
OPEN LS
OPEN SOL
8
* FIELD INSTALLED
G
26
JUMPER
UNIT 2 DSI
SILO
F
FLUIDIZING BIN 1 SOLENOID
REF.
4195-24
1-BK
414520
3-BL
GND
N404100
2-R
02CBD4312
X SP
28
UNIT 2 DSI
SILO
G
FLUIDIZING BIN 2 SOLENOID
30
REF.
4195-27
1-BK
414522
3-BL
GND
N404100
2-R
02CBD4313
X SP
32
UNIT 2 DSI
SILO
EXHAUST FAN
34
REF.
4036-53
1-BK
H403653
2-R
N403653
3-BL
GND
02CBD4108
0 SP
H
L
N
GND
SILO SKIRT ELEVATION
36
SILO SKIRT
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4304
WIRING LEGEND
A
- DENOTES PRE-WIRED
00
REF.
4205-00
1-BK
414300
2-R
N404100
02CBD4314
X SP
1
L1
120
2
L2
VAC
3
*
4-O
4
414328
5
02
6
7
8
3-BL
1 2 3 NO
GND
ON
04
KEY
ON
OFF
* FIELD INSTALLED
NC
JUMPER
B
LOW LEVEL PROBE
06
REF.
4205-04
1-BK
414300
2-R
N404100
02CBD4315
X SP
1
L1
120
2
L2
VAC
3
*
4-O
08
4
414330
5
6
7
8
3-BL
1 2 3 NO
GND
ON
10
KEY
ON
OFF
* FIELD INSTALLED
NC
JUMPER
C
AERATION SOLENOID
12
REF.
4205-11
1-BK
414524
3-BL
GND
N404100
2-R
02CBD4319
X SP
14
16
LOAD CELL 1
18
E
RED
-EXC
A
20
REF.
4175-15
LOAD
02CBA4550
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
22
E
LOAD CELL 2
RED
-EXC
24
REF.
4175-17
LOAD
02CBA4551
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
C
26
LOAD CELL 3
B
RED
-EXC
28
REF.
4175-20
LOAD
02CBA4552
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
30
32
34
36
SCALE 1
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4305
WIRING LEGEND
METERING D.T. RAL MOTOR
A
- DENOTES PRE-WIRED
00
REF.
4117-06
1-BK (BR)411706
02CBG4024
2-BK (O) 411707
0 SP
3-BK (Y) 411708
BARE
2HP
MTR
GND
02
UNIT 2 DSI SILO SCALE 1 METERING
DROP THRU AIRLOCK ZERO SPEED SW
04
REF.
4205-08
1-BK
414300
414332
B
2-R
02CBD4316
X SP
06
DROP THRU AIRLOCK POCKET PURGE SOLENOID
REF.
4205-14
1-BK
414526
3-BL
GND
N404100
C
2-R
02CBD4320
X SP
08
DROP THRU AIRLOCK BEARING PURGE SOLENOID
D
10
REF.
4205-17
1-BK
414528
3-BL
GND
N404100
2-R
02CBD4321
X SP
12
14
16
18
20
22
24
26
28
A
B
C
D
30
32
34
36
SCALE 1
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4306
WIRING LEGEND
A
- DENOTES PRE-WIRED
00
REF.
4215-00
1-BK
414340
2-R
N404100
1
L1
120
2
L2
VAC
02CBD4322
X SP
3
*
4-O
4
414368
5
02
6
7
8
3-BL
1 2 3 NO
GND
ON
04
KEY
ON
OFF
* FIELD INSTALLED
NC
JUMPER
B
LOW LEVEL PROBE
06
REF.
4215-04
1-BK
414340
2-R
N404100
1
L1
120
2
L2
VAC
02CBD4323
X SP
3
*
4-O
08
4
414370
5
6
7
8
3-BL
1 2 3 NO
GND
ON
10
KEY
ON
OFF
* FIELD INSTALLED
NC
JUMPER
C
AERATION SOLENOID
12
REF.
4215-11
1-BK
414564
3-BL
GND
N404100
2-R
02CBD4327
X SP
14
16
LOAD CELL 1
18
E
RED
-EXC
A
20
REF.
4175-55
LOAD
02CBA4554
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
E
22
LOAD CELL 2
RED
-EXC
24
REF.
4175-57
LOAD
02CBA4555
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
C
26
LOAD CELL 3
B
RED
-EXC
28
REF.
4175-60
LOAD
02CBA4556
+SIG
GRN
CELL
-SIG
WHT
+EXC
BLK
30
32
34
36
SCALE 2
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4307
WIRING LEGEND
METERING D.T. RAL MOTOR
A
- DENOTES PRE-WIRED
00
REF.
4127-06
1-BK (BR)412706
02CBG4027
2-BK (O) 412707
0 SP
3-BK (Y) 412708
BARE
2HP
MTR
GND
02
DROP THRU AIRLOCK ZERO SPEED SW
04
REF.
4215-08
1-BK
414340
414372
B
2-R
02CBD4324
X SP
06
DROP THRU AIRLOCK POCKET PURGE SOLENOID
REF.
4215-14
1-BK
414566
3-BL
GND
N404100
C
2-R
02CBD4328
X SP
08
DROP THRU AIRLOCK BEARING PURGE SOLENOID
D
10
REF.
4215-17
1-BK
414568
3-BL
GND
N404100
2-R
02CBD4329
X SP
12
14
16
18
20
22
24
26
28
A
B
C
D
30
32
34
36
SCALE 2
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4308
WIRING LEGEND
- DENOTES PRE-WIRED
UNIT 2 DSI
00
CONVERGING
HOSE SWITCH
A
GND LUG
G
G
02
REF.
4142-57
1-BK
X SP
WIRED TO
DEVICES
AS
NEEDED
414240
02CBD4233
1
1
2-R
N404100
2
2
1A
10-Y/BK 414464
2
3
1B
9-O/BK 414462
04
2
4
2A
8-BL/BK 414460
2
5
2B
7-R/BK 414458
2
6
4-O
414262
BLK
1
WHT
8
RED
9
BLK
414260
06
6-BR
SEAL
POS #2
POS #1
414258
7
5-Y
UNSEAL
10 RED
11
1
WHT
1
POS #1
POS #2
SEALED
12
08
10
12
14
16
18
A
20
22
24
2
PF
26
AF
1
28
N
30
OVERALL PLAN VIEW
32
34
36
HOSE SWITCH
OWENSBORO, KY
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
DRAWN BY
J. ATKINSON
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4309
WIRING LEGEND
1
UNIT 2 DSI DUCT 1
A
LANCE 1 MOV
- DENOTES PRE-WIRED
00
REF.
4225-11
1-BK
422510
02CBD4070
X SP
L1
CL2
HTR
2-R
N403608
3-BL
GND
L2
T2
02
T1
7-R/BK 423043
22
LS4
8-BL/BK 423042
TS18
18C
4
04
18
LS8
9-O/BK 423044
TS17
17C
8
17
LS9
4-O
423000
5-Y
423002
9C
CLOSED LS
9
06
LS5
5C
6-BR
OPEN LS
423004
5
08
UNIT 2 DSI DUCT 1
B
LANCE 2 MOV
10
REF.
4225-13
1-BK
422512
2-R
N403608
3-BL
GND
02CBD4071
X SP
L1
CL2
HTR
L2
T2
T1
12
7-R/BK 423047
22
LS4
8-BL/BK 423046
TS18
18C
4
18
LS8
14
9-O/BK 423048
TS17
17C
8
17
LS9
4-O
423000
5-Y
423006
9C
CLOSED LS
MECHANICAL
LOCATIONS
TO BE DETERMINED
9
LS5
16
5C
6-BR
OPEN LS
423008
5
18
UNIT 2 DSI DUCT 1
C
LANCE 3 MOV
REF.
4225-15
X SP
20
1-BK
422514
2-R
N403608
3-BL
GND
02CBD4072
L1
CL2
HTR
L2
T2
T1
22
7-R/BK 423051
22
LS4
8-BL/BK 423050
TS18
18C
4
18
LS8
9-O/BK 423052
TS17
17C
8
24
17
LS9
4-O
423000
5-Y
423010
9C
CLOSED LS
9
LS5
26
5C
6-BR
OPEN LS
423012
5
UNIT 2 DSI DUCT 1
28
REF.
4225-17
1-BK
422516
2-R
N403608
3-BL
GND
02CBD4073
X SP
30
D
LANCE 4 MOV
L1
CL2
HTR
L2
T2
T1
7-R/BK 423055
22
32
LS4
8-BL/BK 423054
TS18
18C
4
18
LS8
9-O/BK 423056
TS17
17C
8
34
17
LS9
4-O
423000
5-Y
423014
9C
CLOSED LS
9
LS5
5C
36
6-BR
OPEN LS
423016
DUCT 1 LANCE 1-4 VALVES
5
1
26AUG15
0
01JUN15
REV
DATE
UPDATED DEVICES TO PRE-WIRED
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4310
WIRING LEGEND
1
UNIT 2 DSI DUCT 1
A
LANCE 5 MOV
- DENOTES PRE-WIRED
00
REF.
4225-19
1-BK
422518
02CBD4074
X SP
L1
CL2
HTR
2-R
N403608
3-BL
GND
L2
T2
02
T1
7-R/BK 423103
22
LS4
8-BL/BK 423102
TS18
18C
4
04
18
LS8
9-O/BK 423104
TS17
17C
8
17
LS9
4-O
423000
5-Y
423018
9C
CLOSED LS
9
06
LS5
5C
6-BR
OPEN LS
423020
5
08
UNIT 2 DSI DUCT 1
B
LANCE 6 MOV
10
REF.
4225-21
1-BK
422520
2-R
N403608
3-BL
GND
02CBD4075
X SP
L1
CL2
HTR
L2
T2
T1
12
7-R/BK 423107
22
LS4
8-BL/BK 423106
TS18
18C
4
18
LS8
14
9-O/BK 423108
TS17
17C
8
17
LS9
4-O
423000
5-Y
423022
9C
CLOSED LS
MECHANICAL
LOCATIONS
TO BE DETERMINED
9
LS5
16
5C
6-BR
OPEN LS
423024
5
18
UNIT 2 DSI DUCT 1
C
LANCE 7 MOV
REF.
4225-23
X SP
20
1-BK
422522
2-R
N403608
3-BL
GND
02CBD4076
L1
CL2
HTR
L2
T2
T1
22
7-R/BK 423111
22
LS4
8-BL/BK 423110
TS18
18C
4
18
LS8
9-O/BK 423112
TS17
17C
8
24
17
LS9
4-O
423000
5-Y
423026
9C
CLOSED LS
9
LS5
26
5C
6-BR
OPEN LS
423028
5
UNIT 2 DSI DUCT 1
28
REF.
4225-25
1-BK
422524
2-R
N403608
3-BL
GND
02CBD4077
X SP
30
D
LANCE 8 MOV
L1
CL2
HTR
L2
T2
T1
7-R/BK 423115
22
32
LS4
8-BL/BK 423114
TS18
18C
4
18
LS8
9-O/BK 423116
TS17
17C
8
34
17
LS9
4-O
423000
5-Y
423030
9C
CLOSED LS
9
LS5
5C
36
6-BR
OPEN LS
423032
5
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4311
WIRING LEGEND
1
PRESSURE TRANSMITTER PURGE SOLENOID
A
- DENOTES PRE-WIRED
00
REF.
4232-43
1-BK
423242
3-BL
GND
N403608
2-R
02CBD4400
X SP
02
REF.
4232-45
1-BK
423244
3-BL
GND
N403608
B
2-R
02CBD4401
X SP
04
C
06
REF.
4232-47
1-BK
423246
3-BL
GND
N403608
2-R
02CBD4402
X SP
08
10
REF.
4232-49
1-BK
423248
3-BL
GND
N403608
D
2-R
02CBD4403
X SP
12
REF.
4232-51
1-BK
423250
3-BL
GND
N403608
E
2-R
02CBD4404
X SP
14
MECHANICAL
LOCATIONS
TO BE DETERMINED
F
16
REF.
4232-53
1-BK
423252
3-BL
GND
N403608
2-R
02CBD4405
X SP
18
20
REF.
4232-55
1-BK
423254
3-BL
GND
N403608
G
2-R
02CBD4406
X SP
22
REF.
4232-57
1-BK
423256
3-BL
GND
N403608
H
2-R
02CBD4407
X SP
24
26
28
30
32
34
36
DUCT 1 PRESSURE TRANS. PURGE SOLENOIDS
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4312
WIRING LEGEND
1
A
- DENOTES PRE-WIRED
00
REF.
4233-02
1-BK
423300
1-W
423302
1-SH
SHLD
02CBA4580
0 SP
1
2
02
REF.
4233-06
1-BK
423300
1-W
423306
1-SH
SHLD
02CBA4581
0 SP
B
1
2
04
06
REF.
4233-10
1-BK
423300
1-W
423310
1-SH
SHLD
02CBA4582
0 SP
C
1
2
08
REF.
4233-14
1-BK
423300
1-W
423314
1-SH
SHLD
02CBA4583
0 SP
D
1
2
10
12
REF.
4233-18
1-BK
423300
1-W
423318
1-SH
SHLD
02CBA4584
0 SP
E
1
2
14
REF.
4233-22
1-BK
423300
1-W
423322
1-SH
SHLD
02CBA4585
0 SP
F
MECHANICAL
LOCATIONS
TO BE DETERMINED
1
2
16
18
REF.
4233-26
1-BK
423300
1-W
423326
1-SH
SHLD
02CBA4586
0 SP
G
1
2
20
REF.
4233-30
1-BK
423300
1-W
423330
1-SH
SHLD
02CBA4587
0 SP
H
1
2
22
24
26
28
30
32
34
36
DUCT 1 PRESSURE TRANSMITTERS
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4313
WIRING LEGEND
1
UNIT 2 DSI
DUCT 2
A
LANCE 1 MOV
- DENOTES PRE-WIRED
00
REF.
4245-11
1-BK
424510
02CBD4078
X SP
L1
CL2
HTR
2-R
N403609
3-BL
GND
L2
T2
02
T1
7-R/BK 425043
22
LS4
8-BL/BK 425042
TS18
18C
4
04
18
LS8
9-O/BK 425044
TS17
17C
8
17
LS9
4-O
425000
5-Y
425002
9C
CLOSED LS
9
06
LS5
5C
6-BR
OPEN LS
425004
5
08
UNIT 2 DSI
DUCT 2
B
LANCE 2 MOV
10
REF.
4245-13
1-BK
424512
2-R
N403609
3-BL
GND
02CBD4079
X SP
L1
CL2
HTR
L2
T2
T1
12
7-R/BK 425047
22
LS4
8-BL/BK 425046
TS18
18C
4
18
LS8
14
9-O/BK 425048
TS17
17C
8
17
LS9
4-O
425000
5-Y
425006
9C
CLOSED LS
MECHANICAL
LOCATIONS
TO BE DETERMINED
9
LS5
16
5C
6-BR
OPEN LS
425008
5
18
UNIT 2 DSI
DUCT 2
C
LANCE 3 MOV
REF.
4245-15
X SP
20
1-BK
424514
2-R
N403609
3-BL
GND
02CBD4080
L1
CL2
HTR
L2
T2
T1
22
7-R/BK 425051
22
LS4
8-BL/BK 425050
TS18
18C
4
18
LS8
9-O/BK 425052
TS17
17C
8
24
17
LS9
4-O
425000
5-Y
425010
9C
CLOSED LS
9
LS5
26
5C
6-BR
OPEN LS
425012
5
UNIT 2 DSI
28
REF.
4245-17
1-BK
424516
2-R
N403609
3-BL
GND
02CBD4081
X SP
30
DUCT 2
D
LANCE 4 MOV
L1
CL2
HTR
L2
T2
T1
7-R/BK 425055
22
32
LS4
8-BL/BK 425054
TS18
18C
4
18
LS8
9-O/BK 425056
TS17
17C
8
34
17
LS9
4-O
425000
5-Y
425014
9C
CLOSED LS
9
LS5
5C
36
6-BR
OPEN LS
425016
5
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4314
WIRING LEGEND
1
UNIT 2 DSI
DUCT 2
A
LANCE 5 MOV
- DENOTES PRE-WIRED
00
REF.
4245-19
1-BK
424518
02CBD4082
X SP
L1
CL2
HTR
2-R
N403609
3-BL
GND
L2
T2
02
T1
7-R/BK 425103
22
LS4
8-BL/BK 425102
TS18
18C
4
04
18
LS8
9-O/BK 425104
TS17
17C
8
17
LS9
4-O
425000
5-Y
425018
9C
CLOSED LS
9
06
LS5
5C
6-BR
OPEN LS
425020
5
08
UNIT 2 DSI
DUCT 2
B
LANCE 6 MOV
10
REF.
4245-21
1-BK
424520
2-R
N403609
3-BL
GND
02CBD4083
X SP
L1
CL2
HTR
L2
T2
T1
12
7-R/BK 425107
22
LS4
8-BL/BK 425106
TS18
18C
4
18
LS8
14
9-O/BK 425108
TS17
17C
8
17
LS9
4-O
425000
5-Y
425022
9C
CLOSED LS
MECHANICAL
LOCATIONS
TO BE DETERMINED
9
LS5
16
5C
6-BR
OPEN LS
425024
5
18
UNIT 2 DSI
DUCT 2
C
LANCE 7 MOV
REF.
4245-23
X SP
20
1-BK
424522
2-R
N403609
3-BL
GND
02CBD4084
L1
CL2
HTR
L2
T2
T1
22
7-R/BK 425111
22
LS4
8-BL/BK 425110
TS18
18C
4
18
LS8
9-O/BK 425112
TS17
17C
8
24
17
LS9
4-O
425000
5-Y
425026
9C
CLOSED LS
9
LS5
26
5C
6-BR
OPEN LS
425028
5
UNIT 2 DSI
28
REF.
4245-25
1-BK
424524
2-R
N403609
3-BL
GND
02CBD4085
X SP
30
DUCT 2
D
LANCE 8 MOV
L1
CL2
HTR
L2
T2
T1
7-R/BK 425115
22
32
LS4
8-BL/BK 425114
TS18
18C
4
18
LS8
9-O/BK 425116
TS17
17C
8
34
17
LS9
4-O
425000
5-Y
425030
9C
CLOSED LS
9
LS5
5C
36
6-BR
OPEN LS
425032
5
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4315
WIRING LEGEND
1
A
- DENOTES PRE-WIRED
00
REF.
4252-43
1-BK
425242
3-BL
GND
N403609
2-R
02CBD4408
X SP
02
REF.
4252-45
1-BK
425244
3-BL
GND
N403609
B
2-R
02CBD4409
X SP
04
C
06
REF.
4252-47
1-BK
425246
3-BL
GND
N403609
2-R
02CBD4410
X SP
08
10
REF.
4252-49
1-BK
425248
3-BL
GND
N403609
D
2-R
02CBD4411
X SP
12
REF.
4252-51
1-BK
425250
3-BL
GND
N403609
E
2-R
02CBD4412
X SP
14
MECHANICAL
LOCATIONS
TO BE DETERMINED
F
16
REF.
4252-53
1-BK
425252
3-BL
GND
N403609
2-R
02CBD4413
X SP
18
20
REF.
4252-55
1-BK
425254
3-BL
GND
N403609
G
2-R
02CBD4414
X SP
22
REF.
4252-57
1-BK
425256
3-BL
GND
N403609
H
2-R
02CBD4415
X SP
24
26
28
30
32
34
36
DUCT 2 PRESSURE TRANS. PURGE SOLENOIDS
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4316
WIRING LEGEND
1
A
- DENOTES PRE-WIRED
00
REF.
4253-02
1-BK
425300
1-W
425302
1-SH
SHLD
02CBA4588
0 SP
1
2
02
REF.
4253-06
1-BK
425300
1-W
425306
1-SH
SHLD
02CBA4589
0 SP
B
1
2
04
06
REF.
4253-10
1-BK
425300
1-W
425310
1-SH
SHLD
02CBA4590
0 SP
C
1
2
08
REF.
4253-14
1-BK
425300
1-W
425314
1-SH
SHLD
02CBA4591
0 SP
D
1
2
10
12
REF.
4253-18
1-BK
425300
1-W
425318
1-SH
SHLD
02CBA4592
0 SP
E
1
2
14
REF.
4253-22
1-BK
425300
1-W
425322
1-SH
SHLD
02CBA4593
0 SP
F
MECHANICAL
LOCATIONS
TO BE DETERMINED
1
2
16
18
REF.
4253-26
1-BK
425300
1-W
425326
1-SH
SHLD
02CBA4594
0 SP
G
1
2
20
REF.
4253-30
1-BK
425300
1-W
425330
1-SH
SHLD
02CBA4595
0 SP
H
1
2
22
24
26
28
30
32
34
36
DUCT 2 PRESSURE TRANSMITTERS
1
26AUG15
0
01JUN15
REV
DATE
REVISION NOTE
JSA
ADH
JSA
ADH
DRAWN BY
J. ATKINSON
OWENSBORO, KY
DATE
10.Feb.15
DRAWN
DESIGN
DESIGN BY
A. HEUER
SCALE
NONE
c
CATALOG NO.
2007
DRAWING NO.
9190A-7-4317

2.4.a Electrical Drawings DSI System IFC

Transcription

Similar documents

BRAKE PADS - AP Racing