Johnson / Evinrude

Transcription

Johnson / Evinrude

JOHNSON/EVINRUDE
PART III:
JOHNSON/EVINRUDE
SECTION A: COOLING
SECTION E: ELECTRICAL
Impellers ................................. pg. 172
Impeller Kits ............................ pg. 174
Water Pump Kits ...................... pg. 175
Water Pump Components ......... pg. 182
Water Pump Seals & Gaskets .... pg. 188
Water Pump Fasteners ............. pg. 192
Thermostats ............................. pg. 195
Thermostat Kits ........................ pg. 196
Thermostat Components ........... pg. 198
Thermostat Seals & Gaskets ...... pg. 200
Water Hoses ........................... pg. 202
Exhaust Gaskets ...................... pg. 202
Regulators & Rectifiers ................... pg. 298
Ignition Switch .............................. pg. 299
Relays .......................................... pg. 299
SECTION B: ENGINE
Bearing Kits ............................. pg. 204
Bearings ................................. pg. 206
Crankshaft Seals ...................... pg. 210
Engine Seals & Gaskets ............ pg. 211
Powerhead Gasket Sets ............ pg. 225
Head Gaskets .......................... pg. 230
Connecting Rods & Bolts .......... pg. 234
Oil Filters & Accessories ........... pg. 235
SECTION D: GEARCASE
Gearcase Diagram .................. pg. 237
Gearcase Components ............. pg. 245
Bearing Kits ............................. pg. 251
Bearings ................................. pg. 253
Shafts ..................................... pg. 257
Gear Components ................... pg. 260
Gear Sets ................................ pg. 261
Prop Components .................... pg. 267
Anodes & Trim Tabs ................. pg. 273
Seals, O-Rings, & Gaskets ........ pg. 274
Gearcase Fasteners .................. pg. 291
Shims ...................................... pg. 293
www.EngineeredMarineProducts.com
SECTION F: TILT & TRIM
Trim Seals ..................................... pg. 300
Trim Cylinder Repair Kits ............... pg. 301
Motors & Reservoirs ....................... pg. 302
SECTION G: IGNITION
Tune-up Kits .................................. pg. 304
Ignition Coils & Sensors .................. pg. 306
Plug Wires ................................... pg. 307
Power Packs ................................. pg. 308
Solenoids ..................................... pg. 312
Starter Components ...................... pg. 313
SECTION H: FUEL
Carburetor Kits ............................. pg. 316
Fuel Connectors ............................ pg. 318
Fuel Pumps ................................... pg. 320
Fuel Pump Kits .............................. pg. 322
Fuel Seals & Gaskets ..................... pg. 323
Fuel Filters .................................... pg. 325
SPECIAL SECTION:
Fuel Filters & Accessories ............... pg. 326
PAGE 171
JOHNSON/EVINRUDE
(A) COOLING
IMPELLER
47-00008
IMPELLER
replaces:
JEV 0777212
JEV 0385072
85-115 HP FOR 25” TRANSOM
1977-78, 140 HP 1977-78, V6
CROSSFLOW 150/175/200/235
FOR 85 HP & 100 HP 1969-72, 115
HP 1969-70, 125 HP 1971-72
SIE 18-3043
®
SIE 18-3044
®
A01
Impellers
IMPELLER WITH KEY &
O-RING
47-00009
replaces:
A01
Impellers
47-00010
IMPELLER
replaces:
47-00585
replaces:
JEV 5001593
JEV 0434424
FOR V4 ENGINES FROM 1979-UP,
FOR V6 ENGINES FROM 1977-UP
FOR 3 HP 1952-1978, 5 HP 1965-68,
7.5 HP 1954-58
SIE 18-3059
®
SIE 18-3001
®
A01
Impellers
IMPELLER
A01
Impellers
47-00586
IMPELLER
replaces:
JEV 0375638
JEV 0386084
FOR 18-20 HP 1956-73, 25 HP
1969-78
FOR 9.9-15 HP 1974-2002, 8- 9.9-15
HP 4-STROKE 1994-2002
SIE 18-3002
®
SIE 18-3050
®
A01
Impellers
IMPELLER WITH (2) KEYS
47-01750
replaces:
A01
Impellers
IMPELLER WITH KEY
JEV 0395289
FOR 60 HP 3 CYL 1986-2002, 65-70
HP 1979-2002, 75 COMMERCIAL
1979-1988
FOR 25 HP ‘79-84, 20, 25 HP ‘85-02,
25 COMMERCIAL & 28 HP ‘85- 97,
30-35 HP TWIN ‘80-02, 25- 35 HP
‘95-02, 35 HP TWIN ‘78-79
A01
Impellers
PAGE 172
47-01865
replaces:
JEV 0396725
SIE 18-3053
®
47-00587
replaces:
SIE 18-3051
®
A01
Impellers
Customer Service: 1-866-301-0431
JOHNSON/EVINRUDE
47-01877
IMPELLER
replaces:
JEV 0765431
JEV 0777213
FOR 70 HP 1974-78, 65 HP 1972-73
FOR 35 HP 1958-59, 40 HP 1960-70
SIE 18-3082
®
SIE 18-3083
®
A01
Impellers
IMPELLER
A01
Impellers
47-01920
IMPELLER
replaces:
47-01922
replaces:
JEV 0389589
JEV 0777214
FOR 50 HP 1979-85, 60 HP TWIN
CYL 1980-85
FOR 40-48 HP 1984-88, 45-55 COM
‘86-94
SIE 18-3055
®
SIE 18-3368
®
A01
Impellers
IMPELLER
A01
Impellers
47-02028
IMPELLER
replaces:
47-02913
replaces:
JEV 0432941
JEV 0763735
FOR 40/48/50 HP 1989-2002, 45/55
COMMERCIAL 1995-2002
2 JR, COLT, 1985-90/ 4 HP 90°197380/6 HP 1979
SIE 18-3104
®
SIE 18-3090
®
A01
Impellers
IMPELLER
A01
Impellers
47-02914
IMPELLER
replaces:
47-07200
replaces:
JEV 0389576
JEV 0390286
FOR 4 HP DELUXE 1985-88, 4.5- 7.5
HP 1980-84, 6-8 HP 1980- 2002, 5-6
HP 4-STROKE 1982-2002
FOR 40 HP TWIN CYL 1974-76, 40
COM.‘81-87
SIE 18-3091
®
47-01919
replaces:
A01
Impellers
SIE 18-3366
®
A01
Impellers
PAGE 173
(A) COOLING
IMPELLER
JOHNSON/EVINRUDE
(A) COOLING
IMPELLER WITH O-RING
47-08730
replaces:
IMPELLER WITH KEY
47-08731
replaces:
JEV 0765350
JEV 0767407
FOR 40, 48 & 50 HP, 1995 AND UP
FOR 2.5, 3, 4 ULTRA, EXCEL
SIE 18-3104
®
SIE 18-3015
®
A01
Impellers
IMPELLER
A01
Impellers
47-09227
IMPELLER
replaces:
47-09228
replaces:
JEV 0382221
JEV 0763982
1.5, 2 HP (1967-84) & 4 HP 90°
(1973-75)
FOR 35 HP 1976-77
SIE 18-45221
®
®
A01
Impellers
IMPELLER
A01
Impellers
47-13140
IMPELLER
replaces:
47-13142
replaces:
JEV 0377178
JEV 0775521
FOR 9.5 HP 1964-73
FOR 40 HP 1971-73
SIE 18-3003
®
SIE 18-3006
®
A01
Impellers
IMPELLER
47-47202
replaces:
IMPELLER SERVICE KIT
46-02478
replaces:
JEV 0436137
JEV
INCLUDES WATER PUMP KEY. FOR
4-8 HP
FITS 2 JR, COLT 1985-90; 3 HP 195278 AND 4 HP 1969-72
®
SIE 18-3201
®
A01
Impellers
PAGE 174
A01
Impellers
A02
Impeller Kits
JOHNSON/EVINRUDE
46-02479
WATER PUMP SERVICE
KIT
replaces:
JEV
SIE 18-3202
JEV 5001594
SIE 18-3390
FITS 5.5 HP 1954-64; 6 HP 1952-78
AND 7.5 HP 1954-58
®
46-00012
replaces:
FOR KIT WITH HOUSING SEE 46-00013
OR 46- 07300.
®
A02
Impeller Kits
A03
Water Pump Kits
COMPONENT
46-02480
replaces:
JEV
SIE 18-3203
FITS 10 HP 1949-57; 15 & 18 HP
1952-65; 20 HP 1966-73 & 25 HP
1969-78
®
A02
Impeller Kits
COMPLETE WATER
PUMP KIT
46-00013
10-01759
10-05189
10-05194
25-00205
25-01405
25-02440
25-07710
26-01455
26-01456
26-01457
26-01458
27-00976
46-01398
46-01399
46-09930
47-00010
47-01408
JEV 5001594
DESCRIPTION
Bolt
Screw (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Grommet
Seal (Pack of 5)
Gasket
Water Pump Housing
Wear Plate
Water Pump Cup
Water Pump Cover
Impeller with Key & O-Ring
Impeller Key (Pack of 3)
4
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
46-00094
replaces:
JEV 0395072
FOR V4 & V6 ENGINES. KIT
DESIGNED TO REPLACE OLD DESIGN
PUMP HOUSING # 393508 (1976-78)
NOTE: IMPELLER NOT INCLUDED.
A03
Water Pump Kits
10-05189
10-05194
25-00205
25-01405
25-02440
25-07710
26-01455
26-01456
26-01457
26-01458
27-00976
46-00011
46-01398
46-01399
46-09930
47-00010
47-01408
QTY
SIE 18-3391
CONTAINS HOUSING WITH BLEED
HOLE. IF HOUSING HAS NO BLEED
HOLE (RELIEF HOLE) USE 46-07300.
COMPONENT
Bolt
Bolt
Screw (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Grommet
Seal (Pack of 5)
Gasket
Wear Plate
Water Pump Cup
Water Pump Cover
WATER PUMP HOUSING
KIT
replaces:
SIE 18-3392
®
DESCRIPTION
A03
Water Pump Kits
QTY
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
10-01758
10-05189
25-01405
26-01456
26-01458
27-00976
46-00011
46-01399
47-01408
DESCRIPTION
Bolt
Bolt
O-Ring
Grommet
Seal (Pack of 5)
Gasket
Water Pump Housing
Water Pump Cup
QTY
1
4
1
1
1
1
1
1
1
PAGE 175
(A) COOLING
JOHNSON/EVINRUDE
(A) COOLING
WATER PUMP KIT WITH
HOUSING
46-00095
WATER PUMP SERVICE
KIT
replaces:
JEV 0395073
FOR 85 HP (1977-78), 115 HP (197778), 140 HP (1977-78), 150-175-200235 HP
FOR EARLY MODEL 50 HP
®
A03
Water Pump Kits
A03
Water Pump Kits
COMPONENT
10-05189
10-05194
25-00023
25-00205
26-01455
26-01456
26-01457
26-01458
27-00975
27-00976
46-00011
46-01398
46-01399
46-09930
47-00008
47-01407
DESCRIPTION
Bolt
Screw (Pack of 5)
O-Ring
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Grommet
Seal (Pack of 5)
Shift Rod Cover Gasket
Gasket
Water Pump Housing
Wear Plate
Water Pump Cup
Water Pump Cover
Impeller
Key (Pack of 5)
WATER PUMP KIT WITH
HOUSING
JEV 0389133
SIE 18-3325
SIE 18-3393
®
46-01826
replaces:
COMPONENT
QTY
10-02160
10-05189
25-00495
25-01923
26-01756
26-01924
27-01936
46-01914
46-01915
46-01916
46-01929
46-01938
47-01407
47-01919
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
46-01873
DESCRIPTION
Pivot Screw
Bolt
O-Ring (Pack of 5)
Seal
Grommet
Grommet
Water Pump Gasket
Wear Plate
Water Pump Liner
Wear Plate
Water Pump Housing
Guide Tube
Key (Pack of 5)
Impeller
WATER PUMP SERVICE
KIT
replaces:
JEV 0432955
SIE 18-3389
QTY
2
2
1
1
1
1
1
1
1
1
1
1
1
1
46-01875
replaces:
JEV 0438579
SIE 18-3388
DOES NOT CONTAIN HOUSING.
®
®
A03
Water Pump Kits
COMPONENT
10-01758
10-02164
25-00063
25-00205
25-00209
26-01455
26-01756
27-01936
46-01751
46-01752
46-01755
46-46006
47-01750
47-01757
47-01760
PAGE 176
DESCRIPTION
Bolt
Bolt (Pack of 4)
Seal
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Water Pump Gasket
Water Pump Housing
Water Tube Guide
Wear Plate
Water Pump Cup
Impeller with (2) Keys
A03
Water Pump Kits
QTY
1
4
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
10-01758
10-01759
26-01455
26-01756
27-00781
46-01752
46-01755
46-46006
47-01407
47-01877
DESCRIPTION
Bolt
Bolt
Grommet (Pack of 5)
Grommet
Water Pump Gasket
Water Tube Guide
Wear Plate
Water Pump Cup
Key (Pack of 5)
Impeller
QTY
1
4
1
1
1
1
1
1
1
1
JOHNSON/EVINRUDE
46-01917
WATER PUMP SERVICE
KIT
replaces:
JEV 0438592
SIE 18-3394
46-02358
replaces:
JEV 0391698
SIE 18-3400
FOR 9.9-15 HP ‘74-UP, 8-9.9-15 HP
4-STROKE ‘94-UP
®
®
A03
Water Pump Kits
COMPONENT
10-02164
25-00063
26-01756
26-01928
27-01936
46-01755
46-46006
47-01757
47-02028
DESCRIPTION
Bolt (Pack of 4)
Seal
Grommet
Grommet
Water Pump Gasket
Wear Plate
Water Pump Cup
Impeller
WATER PUMP KIT WITH
HOUSING
A03
Water Pump Kits
QTY
COMPONENT
4
1
1
1
1
1
1
1
1
46-02855
10-02164
25-00163
25-00273
26-00069
26-01882
26-02353
26-08531
46-02354
46-02356
47-00587
47-02357
DESCRIPTION
Bolt (Pack of 4)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Grommet
Grommet
Grommet
Water Pump Cup
Wear Plate
Impeller
Impeller Pin
WATER PUMP SERVICE
KIT
replaces:
JEV 0394711
SIE 18-3327
4
1
1
1
1
1
1
1
1
1
1
46-02856
replaces:
JEV 0393509
SIE 18-3381
FOR 9.9-15 HP 1974-UP AND 9.9-15
HP 4-STROKE 1994-UP
®
QTY
®
A03
Water Pump Kits
A03
Water Pump Kits
COMPONENT
25-00163
25-00273
26-00069
26-01882
26-02353
26-08531
46-02354
46-02356
46-02912
47-00587
47-02357
DESCRIPTION
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Grommet
Grommet
Grommet
Water Pump Cup
Wear Plate
Water Pump Housing
Impeller
Impeller Pin
QTY
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
10-01759
25-00029
25-00158
25-00165
25-01437
26-01882
27-00979
46-01880
46-01883
47-01865
47-01881
DESCRIPTION
Bolt
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Grommet
Water Pump Gasket
Wear Plate
Water Pump Cup
Impeller with Key
QTY
6
1
1
1
2
1
1
1
1
1
1
PAGE 177
(A) COOLING
WATER PUMP SERVICE
KIT
JOHNSON/EVINRUDE
(A) COOLING
WATER PUMP KIT WITH
HOUSING
46-02857
COMPLETE WATER PUMP
KIT
replaces:
JEV 0393630
®
FOR 40-48 HP 1984-88, 50 HP 197985, 45- 55 COMMERCIAL, 1986-94 &
60 TWIN 1980-85
®
A03
Water Pump Kits
A03
Water Pump Kits
10-05221
25-00029
25-00158
25-00165
25-01437
26-01882
27-00979
46-01880
46-01883
46-02911
47-01865
47-01881
DESCRIPTION
Screw
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Grommet
Water Pump Gasket
Wear Plate
Water Pump Cup
Water Pump Housing
Impeller with Key
COMPLETE WATER PUMP
KIT
COMPONENT
QTY
10-02160
10-03369
25-00495
25-01923
26-01756
26-01924
27-01936
46-01914
46-01915
46-01916
46-01929
46-01938
47-01760
47-01881
47-01922
6
1
1
1
2
1
1
1
1
1
1
1
46-07300
JEV 0435929
CONTAINS HOUSING WITHOUT
BLEED HOLE. IF HOUSING HAS A
BLEED HOLE (RELIEF HOLE) USE THE
46-00013.
10-02164
10-05194
25-01405
25-02440
25-07710
26-01455
26-01456
26-01457
26-08530
27-00976
46-01398
46-01399
46-08011
46-09910
46-09920
46-09930
47-00010
47-01408
PAGE 178
DESCRIPTION
Bolt (Pack of 4)
Screw (Pack of 5)
O-Ring
O-Ring
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Grommet
Grommet
Gasket
Wear Plate
Water Pump Cup
Water Pump Housing
Tube
Tube
Water Pump Cover
QTY
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
46-07410
replaces:
JEV 0395270
SIE 18-3383
FOR 20-25 HP (SOME 1978-1984)
®
A03
Water Pump Kits
COMPONENT
DESCRIPTION
Pivot Screw
Bolt
O-Ring (Pack of 5)
Seal
Grommet
Grommet
Water Pump Gasket
Wear Plate
Water Pump Liner
Wear Plate
Water Pump Housing
Guide Tube
Impeller
WATER PUMP KIT WITH
HOUSING
replaces:
SIE 18-3315-2
®
JEV 0439077
SIE 18-3399
SIE 18-3382
COMPONENT
46-07000
replaces:
A03
Water Pump Kits
QTY
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
10-01759
26-01882
27-00974
27-00996
27-07440
46-01883
46-02619
46-46002
47-01865
47-01881
DESCRIPTION
Bolt
Grommet
Water Pump Gasket
Water Pump Gasket
O-Ring
Water Pump Cup
Wear Plate
Water Pump Housing
Impeller with Key
QTY
4
1
1
1
2
1
1
1
1
1
JOHNSON/EVINRUDE
46-12245
replaces:
JEV 0438592
46-13167
(A) COOLING
WATER PUMP KIT WITH
HOUSING
replaces:
JEV 0391631
SIE 18-3454
SIE 18-3238
FITS 35 HP 1978-79
®
®
A03
Water Pump Kits
COMPONENT
DESCRIPTION
Bolt (Pack of 4)
Seal
Grommet
Grommet
Water Pump Gasket
Wear Plate
Water Pump Housing
Water Pump Cup
Impeller
10-02164
25-00063
26-01756
26-01928
27-01936
46-01755
46-12480
46-46006
47-01757
47-02028
A03
Water Pump Kits
QTY
COMPONENT
4
1
1
1
1
1
1
1
1
1
10-01759
25-01437
26-01048
27-13001
27-13002
46-02918
47-01865
47-02357
DESCRIPTION
Bolt
O-Ring (Pack of 5)
Driveshaft / Propshaft Seal
Water Pump Gasket
Water Pump Gasket
Wear Plate
Impeller with Key
Impeller Pin
QTY
4
2
1
1
1
1
1
1
®
®
46-13162
A03
Water Pump Kits
COMPONENT
25-00023
25-00205
27-00976
46-01398
47-00008
replaces:
JEV
SIE 18-3210
FITS 135 HP 1973-75, 175 HP 1977-78. USES
RECTANGULAR KEY-WAY
DESCRIPTION
O-Ring
O-Ring (Pack of 5)
Gasket
Wear Plate
Impeller
QTY
1
1
1
1
1
replaces:
46-13163
JEV
A03
Water Pump Kits
FOR ENGINES USING NEWER DESIGN
PLASTIC WEDGE-SHAPED IMPELLER KEY
FROM 85 HP V4 -235 HP V6
COMPONENT
25-00023
25-00205
27-00976
46-01398
47-00010
47-01757
47-01881
SIE 18-3211
DESCRIPTION
O-Ring
O-Ring (Pack of 5)
Gasket
Wear Plate
QTY
1
1
1
1
1
1
1
PAGE 179
JOHNSON/EVINRUDE
(A) COOLING
®
®
46-13179
A03
Water Pump Kits
replaces:
JEV 0382468
SIE 18-3377
FITS 15, 18 HP 1953-65; 20 HP 1966-73 AND
25 HP 1969-78
COMPONENT
10-10140
26-01882
46-13155
46-46001
47-00586
46-13187
DESCRIPTION
Water Pump Screw
Grommet
Impeller Plate
Impeller Pin
Impeller
A03
Water Pump Kits
QTY
SIE 18-3402
FOR EARLIER MODEL ENGINES. FITS 9.5 HP
1964-73 AND 10 HP 1958-63
COMPONENT
3
1
1
1
1
46-13182
replaces:
JEV 0382296
10-10141
26-01045
26-01882
27-00964
46-02507
46-46001
47-13140
DESCRIPTION
Water Pump Screw
Grommet
Water Pump Gasket
Wear Plate
Impeller Pin
Impeller
WATER PUMP SERVICE
KIT
replaces:
JEV 0386124
SIE 18-3384
4
1
1
1
1
1
1
46-13186
replaces:
JEV 0395271
SIE 18-3401
FITS 85 1973-77, 115 1973-76, 135
1973-75
®
QTY
FOR 20 HP 1982-1984; 25 HP 19791984; 28 HP 1986 AND UP
®
A03
Water Pump Kits
COMPONENT
10-05189
10-05194
25-00205
26-00024
26-82389
26-82390
46-46110
47-00008
47-01407
PAGE 180
DESCRIPTION
Bolt
Screw (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Grommet
Grommet
Wear Plate
Impeller
Key (Pack of 5)
A03
Water Pump Kits
QTY
4
2
1
1
2
1
1
1
1
COMPONENT
10-01759
26-00174
26-01882
27-00974
27-00996
27-07440
46-01883
46-02619
47-01865
47-01881
47-02357
DESCRIPTION
Bolt
Seal
Grommet
Water Pump Gasket
Water Pump Gasket
O-Ring
Water Pump Cup
Wear Plate
Impeller with Key
Impeller Pin
QTY
4
1
1
1
1
2
1
1
1
1
1
JOHNSON/EVINRUDE
PAGE 181
JOHNSON/EVINRUDE
(A) COOLING
WATER PUMP SERVICE
KIT
46-13188
WATER PUMP KIT WITH HOUSING
replaces:
JEV 0388644
SIE 18-3403
FOR OLDER V4 PUMPS REQUIRING
OIL SEAL IN THE UPPER HOUSING
AND USING IMPELLER 389642
®
®
A03
Water Pump Kits
COMPONENT
10-05189
10-05194
25-00023
25-00205
26-01455
26-01456
26-01457
26-01458
27-00975
27-00976
46-01398
46-01399
46-09930
47-00008
47-01407
DESCRIPTION
Bolt
Screw (Pack of 5)
O-Ring
O-Ring (Pack of 5)
Grommet (Pack of 5)
Grommet
Grommet
Seal (Pack of 5)
Gasket
Wear Plate
Water Pump Cup
Water Pump Cover
Impeller
Key (Pack of 5)
IMPELLER KEY (PACK OF
5)
46-47204
replaces:
JEV 0335956
QTY
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
46-46115
A03
Water Pump Kits
replaces:
JEV 0763736
2 HP (1976-85), 2 HP COLT (1985-90), 4 HP
(1976-84)
COMPONENT
25-00436
47-02913
10-10130
26-26601
46-46133
46-46135
DESCRIPTION
O-Ring
Impeller
Water Pump Screw
Water Tube Grommet
Water Pump Spacer
Impeller Pin
3)
QTY
1
1
2
1
1
1
47-01408
replaces:
JEV 0331107
SIE 18-3299
PACK OF 3
A04
Water Pump Comp
3)
47-01757
replaces:
JEV 0334897
SIE 18-3138
PAGE 182
A04
Water Pump Comp
3)
47-01760
replaces:
JEV 0331901
PACK OF 3
PACK OF 3
A04
Water Pump Comp
A04
Water Pump Comp
JOHNSON/EVINRUDE
47-01881
replaces:
IMPELLER PIN
JEV 0344470
SIE 18-3326
PACK OF 3
A04
Water Pump Comp
A04
Water Pump Comp
WEAR PLATE
46-46135
replaces:
IMPELLER PIN
46-46001
replaces:
JEV 0321130
JEV 0300771
A04
Water Pump Comp
A04
Water Pump Comp
46-01398
replaces:
SIE 18-3326
WEAR PLATE
46-01753
replaces:
JEV 0338485
JEV 0321940
FOR V4/V6/V8 ENGINES USED W/
338486 CUP
FOR 40-75 HP
SIE 18-3346
SIE 18-3126
A04
Water Pump Comp
WEAR PLATE
replaces:
JEV 0300611
SIE 18-3295
IMPELLER PIN
47-02357
46-01880
replaces:
(A) COOLING
3)
A04
Water Pump Comp
WEAR PLATE
46-01914
replaces:
JEV 0328755
JEV 0320776
FOR 10-35 HP
FOR 40-50 HP. USED W/320775 LINER
A04
Water Pump Comp
A04
Water Pump Comp
SIE 18-3359
PAGE 183
JOHNSON/EVINRUDE
(A) COOLING
WEAR PLATE
46-01916
replaces:
WEAR PLATE
JEV 0320981
JEV 0341038
SIE 18-3343
SIE 18-3127
FOR 40-50 HP
A04
Water Pump Comp
A04
Water Pump Comp
WEAR PLATE
46-02356
replaces:
WEAR PLATE
JEV 0305303
FOR 9.9-15 HP
5.5 / 6 / 7.5 / 9.5 / 10 HP
SIE 18-3102
A04
Water Pump Comp
46-02619
replaces:
A04
Water Pump Comp
WEAR PLATE
JEV 0323251
FOR 25 HP
FOR 35 HP
46-02919
replaces:
JEV 0325398
SIE 18-3352
FOR 40 HP
A04
Water Pump Comp
PAGE 184
46-02918
replaces:
JEV 0329391
SIE 18-3181
A04
Water Pump Comp
WEAR PLATE
46-02507
replaces:
JEV 0318995
SIE 18-3178
WEAR PLATE
46-01918
replaces:
A04
Water Pump Comp
IMPELLER PLATE
46-13155
replaces:
JEV 0303069
SIE 18-3103
A04
Water Pump Comp
JOHNSON/EVINRUDE
46-46110
replaces:
WEAR PLATE
JEV 0763732
85 & 115 HP 1973-77 135 HP 197376
2 / 2 COLT / 4 HP
A04
Water Pump Comp
A04
Water Pump Comp
46-46003
replaces:
WATER PUMP CUP
JEV 0338486
CONTAINS 46- 1398 & 46-01399.
FOR V4/V6/V8 ENGINES
FOR V4, V6, & V8 ENGINES. USED
WITH 338486 WEAR PLATE
A04
Water Pump Comp
A04
Water Pump Comp
46-01883
replaces:
WATER PUMP CUP
JEV 0328751
SIE 18-3179
FOR 9.9-15 HP
A04
Water Pump Comp
46-02916
replaces:
46-02354
replaces:
JEV 0324097
SIE 18-3358
WATER PUMP CUP
46-01399
replaces:
JEV 0435027
SIE 18-3346
WATER PUMP CUP
replaces:
JEV 0317841
SIE 18-3182
WATER PUMP CUP AND
WEAR PLATE
46-46111
(A) COOLING
WEAR PLATE
A04
Water Pump Comp
WATER PUMP CUP
46-46006
replaces:
JEV 0325397
JEV 0340619
A04
Water Pump Comp
A04
Water Pump Comp
SIE 18-3353
SIE 18-3455
PAGE 185
JOHNSON/EVINRUDE
(A) COOLING
WATER PUMP CUP
46-46113
replaces:
WATER PUMP LINER
JEV 0321128
46-01915
replaces:
JEV 0320775
USED WITH 320776 WEAR PLATE
A04
Water Pump Comp
WATER PUMP LINER
46-46130
replaces:
A04
Water Pump Comp
WATER TUBE GUIDE
JEV 0763983
46-01752
replaces:
JEV 0319276
FOR COBRA
A04
Water Pump Comp
A04
Water Pump Comp
GUIDE TUBE
TUBE
46-01938
replaces:
TUBE
46-09910
replaces:
JEV 0315838
JEV 0338667
FOR V4, V6, AND V8 ENGINES
LONG TUBE FOR V4, V6, AND V8
ENGINES
A04
Water Pump Comp
A04
Water Pump Comp
46-09920
replaces:
JEV 0338636
TUBE (PACK OF 10)
46-09920-10
replaces:
JEV 0338636
SHORT TUBE FOR V4, V6, AND V8
ENGINES
A04
Water Pump Comp
PAGE 186
A04
Water Pump Comp
JOHNSON/EVINRUDE
WATER PUMP HOUSING
46-09930
replaces:
WATER PUMP HOUSING
JEV 0435990
A04
Water Pump Comp
A04
Water Pump Comp
46-01751
replaces:
SIE 18-3130
WATER PUMP HOUSING
46-01929
replaces:
JEV 0436954
JEV 0384087
A04
Water Pump Comp
A04
Water Pump Comp
46-02911
replaces:
SIE 18-3336
WATER PUMP HOUSING
JEV 0393632
SIE 18-3180
FOR 9.9-15 HP
A04
Water Pump Comp
46-08011
replaces:
46-02912
replaces:
JEV 0435390
SIE 18-3367
WATER PUMP HOUSING
replaces:
JEV 0338893
SIE 18-3129
WATER PUMP HOUSING
46-00011
A04
Water Pump Comp
WATER PUMP HOUSING
46-12480
replaces:
JEV 0435959
JEV 0438544
A04
Water Pump Comp
A04
Water Pump Comp
SIE 18-3405
(A) COOLING
WATER PUMP COVER
PAGE 187
JOHNSON/EVINRUDE
(A) COOLING
WATER PUMP HOUSING
46-26159
replaces:
WATER PUMP HOUSING
JEV 0438543
46-46002
replaces:
JEV 0330560
SIE 18-3363
FOR 25, 25 COMMERCIAL, 28 HP
A04
Water Pump Comp
WATER PUMP HOUSING
46-46131
replaces:
A04
Water Pump Comp
GASKET
JEV 0383663
27-00784
replaces:
JEV 0308592
SIDE WATER PASS GASKET
A04
Water Pump Comp
GASKET
27-00976
replaces:
A05
Water Pump Seals & Gaskets
WATER PUMP GASKET
JEV 0338484
JEV 0325537
FOR WATER PUMP OF V4, V6, V8
FOR IMPELLER PLATE OF 2 AND 3
CYL 20-35 HP ENGINES
SIE 18-2557
SIE 18-0124
A05
WATER PUMP GASKET
27-01936
replaces:
JEV 0336530
SIE 18-2709
FOR WEAR PLATE OF 2 CYL 40-50
HP ENGINES
A05
PAGE 188
27-00979
replaces:
A05
WATER PUMP GASKET
27-13001
replaces:
JEV 0323312
SIE 18-0445
A05
JOHNSON/EVINRUDE
27-13002
replaces:
WATER PUMP GASKET
JEV 0323311
JEV 0329390
SIE 18-0446
SIE 18-3360
FOR IMPELLER HOUSING OF 20-25
HP ENGINES
A05
WATER PUMP GASKET
27-00781
replaces:
JEV 0319586
A05
DRAIN SCREW GASKET
(PACK OF 5)
SIE 18-0969
26-01456
A05
GROMMET
26-01457
replaces:
JEV 0320943
JEV 0321008
A05
A05
SIE 18-2704
GROMMET
JEV 0311598
FOR DRAIN SCREW.
PACK OF 5
A05
replaces:
27-00957
replaces:
SIE 18-4248
FOR IMPELLER HOUSING
GROMMET
27-00974
replaces:
26-01756
replaces:
SIE 18-2706
GROMMET
26-01766
replaces:
JEV 0341732
JEV 0908594
A05
A05
SIE 18-2705
PAGE 189
(A) COOLING
WATER PUMP GASKET
JOHNSON/EVINRUDE
(A) COOLING
GROMMET
26-01882
replaces:
GROMMET
JEV 0302497
JEV 0315837
FOR 9.9-35 HP
FOR 40-50 HP
SIE 18-3329
SIE 18-3337
A05
GROMMET
26-01928
replaces:
A05
GROMMET
JEV 0327035
A05
A05
26-02915
replaces:
SIE 18-2392
GROMMET
PAGE 190
26-08530
replaces:
JEV 0304026
JEV 0338601
A05
A05
SIE 18-3332
GROMMET
26-02353
replaces:
JEV 0333758
SIE 18-2708
GROMMET
26-01924
replaces:
26-08531
replaces:
WATER TUBE GROMMET
26-26601
replaces:
JEV 0342870
JEV 0321129
A05
A05
JOHNSON/EVINRUDE
26-82389
replaces:
GROMMET (PACK OF 5)
JEV 0314832
SIE 18-2703
PACK OF 5
A05
46-46133
replaces:
replaces:
JEV 0314008
SIE 18-2389
WATER PUMP SPACER
26-01455
(A) COOLING
GROMMET
A05
SEAL
JEV 0321126
26-01913
replaces:
JEV 0305762
SIE 18-2532
FOR 2 CYL
A05
EXHAUST SEAL
26-01610
replaces:
A05
EXHAUST SEAL
JEV 0320961
JEV 0324937
SIE 18-8353
SIE 18-2537
FOR SOME 20-75 HP ENGINES
A05
SEAL
25-01923
replaces:
26-00074
replaces:
A05
SEAL
25-00063
replaces:
JEV 0315788
JEV 0324981
FOR WATER PUMP
MOLDED SEAL FOR 2 AND 3 CYL
ENGINE WATER PUMPS
A05
SIE 18-7481
A05
PAGE 191
JOHNSON/EVINRUDE
(A) COOLING
SPAGHETTI SEAL 40”
26-00156
replaces:
SEAL (PACK OF 5)
JEV 0309044
JEV 0332000
SIE 18-2534
SIE 18-2769
FOR WATER PUMP.
PACK OF 5
A05
O-RING (PACK OF 5)
25-00163
replaces:
A05
O-RING (PACK OF 5)
JEV 0310585
PACK OF 5
PACK OF 5
SIE 18-7158
A05
25-00213
replaces:
A05
O-RING (PACK OF 5)
JEV 0314491
PACK OF 5
PACK OF 5
SIE 18-7129
A05
25-00264
replaces:
A05
O-RING
25-00023
replaces:
JEV 0310584
JEV 0321120
PACK OF 5
FOR WATER PUMP. V4 & V6
ENGINES.
PACK OF 5
SIE 18-7135
A05
PAGE 192
25-00262
replaces:
JEV 0305270
SIE 18-7155
O-RING (PACK OF 5)
25-00205
replaces:
JEV 0319085
SIE 18-7139
O-RING (PACK OF 5)
26-01458
replaces:
SIE 18-2536
A05
JOHNSON/EVINRUDE
25-00029
replaces:
O-RING
JEV 0328753
SIE 18-7419
FOR WATER PUMP OF 2 CYL 20-35
HP ENGINES
A05
A05
25-01405
replaces:
O-RING
WATER PUMP SCREW
25-25951
replaces:
JEV 0331353
JEV 0304174
A05
A05
SIE 18-7963
WATER INTAKE SCREW
replaces:
JEV 0338518
SIE 18-2539
O-RING
25-01076
(A) COOLING
O-RING
10-10110
replaces:
SIE 18-7165
WATER PUMP SCREW
10-10130
replaces:
JEV 0340665
JEV 0321127
A06
Water Pump Fasteners
A06
10-10140
replaces:
WATER PUMP SCREW
10-10141
replaces:
JEV 0302508
JEV 0303395
A06
A06
PAGE 193
JOHNSON/EVINRUDE
(A) COOLING
SCREW
10-05221
replaces:
SCREW (PACK OF 5)
JEV 0328725
10-05194
replaces:
JEV 0306643
SIE 18-3135
PACK OF 5
A06
SCREW
10-01956
replaces:
A06
PIVOT SCREW
JEV 0331980
JEV 0909533
A06
A06
SIE 18-1704
BOLT (PACK OF 4)
10-02164
replaces:
SIE 18-3365
BOLT
JEV 0302325
SIE 18-3153
PACK OF 4
A06
A06
10-01759
replaces:
BOLT
10-01889
replaces:
JEV 0331979
JEV 0324334
A06
A06
SIE 18-3133
PAGE 194
10-01758
replaces:
JEV 0908158
SIE 18-3369
BOLT
10-02160
replaces:
SIE 18-4276
JOHNSON/EVINRUDE
10-01945
replaces:
BOLT
JEV 0319126
A06
A06
10-05189
replaces:
SIE 18-3369
THERMOSTAT (S.S.)
JEV 0323626
SIE 18-3543
FOR 6-55 HP CROSS V4 & V6, 9.915 HP; 4 STROKE 1994-UP
A06
75-00422
replaces:
A07
Thermostats
THERMOSTAT 143 DEG.
75-08630
replaces:
JEV 0396987
JEV 0434137
FOR 3 CYL (49 CU. IN)
FOR 3 CYL (56 CU. IN) 1992-UP; 90°
LOOPER 1990-92
SIE 18-3557
SIE 18-3500
A07
Thermostats
THERMOSTAT 143 DEG.
75-00403
replaces:
JEV 5005440
SIE 18-3136
THERMOSTAT 143 DEG.
replaces:
JEV 0324430
SIE 18-4277
BOLT
10-03369
(A) COOLING
BOLT
75-08631
replaces:
A07
Thermostats
THERMOSTAT 130 DEG.
75-08633
replaces:
JEV 0435491
JEV 0437090
FOR 90-115 HP LOOPER 1995-UP;
150-175 HP 1991-UP
FOR V6 OFFSHORE MODEL
STAINLESS STEEL
SIE 18-3544
A07
Thermostats
SIE 18-3545
A07
Thermostats
PAGE 195
JOHNSON/EVINRUDE
(A) COOLING
THERMOSTAT
VERNATHERM 143 DEG.
75-08672
replaces:
THERMOSTAT 130 DEG.
JEV 0433379
JEV 5001036
A07
Thermostats
A07
Thermostats
75-08632
replaces:
SIE 18-3546
VERNATHERM
JEV 0384719
FOR 40/48/50 HP 1995-UP; 3 CYL
1993-UP; V4 LOOPER 1993-UP
FOR MOST 3 & 4 CYL MOTORS
1985-90
SIE 18-3560
A07
Thermostats
75-08675
replaces:
A07
Thermostats
THERMOSTAT & COVER
JEV 0435597
A07
Thermostats
A08
Thermostat Kits
75-02380
replaces:
JEV
0307239/0312797/3853983
SIE 18-3676D
A08
Thermostat Kits
PAGE 196
75-08640
replaces:
JEV 0394411
SIE 18-1506
THERMOSTAT KIT 140
DEG.
75-08634
replaces:
JEV 0436195
SIE 18-3561
VERNATHERM
75-75010
replaces:
THERMOSTAT KIT 160
DEG.
75-01559
replaces:
JEV
0313416/0314809/3853799
SIE 18-3670D
A08
Thermostat Kits
JOHNSON/EVINRUDE
75-02658
A08
Thermostat Kits
26-02651
27-00760
27-00952
75-00403
75-02652
75-02653
THERMOSTAT KIT
replaces:
JEV NONE
FOR V4 CROSSFLOW - THERMOSTAT
SUPERSEDED TO 5005440
DESCRIPTION
Grommet
Gasket (Pack of 5)
Thermostat Cover Gasket
Thermostat (S.S.)
Valve
Valve Spring
replaces:
JEV NONE
75-75008
SIE 18-3673
COMPONENT
(A) COOLING
SS THERMOSTAT KIT (DUAL)
QTY
2
2
2
2
2
2
A08
Thermostat Kits
COMPONENT
DESCRIPTION
Thermostat Spring
O-Ring
Thermostat Gasket
Thermostat 130 Deg.
Thermostat Plug
24-24110
25-02440
27-08518
75-08633
75-75003
STAINLESS STEEL
THERMOSTAT KIT
THERMOSTAT
QTY
1
1
1
1
1
75-02659
replaces:
JEV
SIE 18-3674
FOR V6 CROSSFLOW - THERMOSTAT
SUPERSEDED TO 5005440
A08
Thermostat Kits
COMPONENT
75-75009
26-01960
27-00424
27-00949
75-00403
75-02653
75-02654
75-02655
75-02656
75-02657
replaces:
JEV
SIE 18-3669
A08
Thermostat Kits
COMPONENT
27-00777
27-00946
75-00422
DESCRIPTION
Thermostat Gasket
Thermostat 143 Deg.
DESCRIPTION
Grommet
Thermostat Gasket
Thermostat (S.S.)
Valve Spring
Retainer
Diaphragm
Valve
Washer Valve
QTY
1
1
1
1
1
1
1
1
1
QTY
1
1
1
PAGE 197
JOHNSON/EVINRUDE
(A) COOLING
THERMOSTAT ASSEMBLY
75-08673
replaces:
ELBOW
JEV 0434067
JEV 0321886
FOR 6-8 HP 1991 AND UP
FITS 9.9-15 1978-95, 20-35 HP 197880 3 CYL, V4 1978-UP, V6 1978-82,
40-60 2 CYL 1978-90, 1978-91
SIE 18-3290
A08
Thermostat Kits
ELBOW
12-02781
replaces:
12-02782
replaces:
A09
Thermostat Components
ELBOW
JEV 0331894
12-03671
replaces:
JEV 0126776
SIE 18-3566
FITS V6 1987-90 (LOOP CHARGE.
W/ POWER STEERING) & V8 198691 (W/ POWER STEERING)
A09
A09
VALVE DIAPHRAGM
75-02210
replaces:
JEV 0394408
DIAPHRAGM & CUP
ASSEMBLY
SIE 18-1222
FOR 2 CYL THERMOSTAT
A09
75-02655
replaces:
A09
VALVE
75-02652
replaces:
JEV 0321221
JEV 0318395
FITS V6 CROSSFLOW
FITS V4 CROSSFLOW
SIE 18-3567
A09
PAGE 198
JEV 0435957
SIE 18-3501
FITS V4 & LOOP CHARGED
MOTORS
DIAPHRAGM
75-08521
replaces:
SIE 18-3564
A09
JOHNSON/EVINRUDE
75-02656
replaces:
RETAINER
JEV 0321027
JEV 0321220
FITS V6 CROSSFLOW
FITS V6 CROSSFLOW
SIE 18-3563
SIE 18-3565
A09
WASHER VALVE
75-02654
replaces:
75-02657
replaces:
A09
THERMOSTAT SPRING
JEV 0321222
24-24110
replaces:
JEV 0337067
SIE 18-3562
FITS V6 CROSSFLOW
A09
A09
VALVE SPRING
75-02653
replaces:
THERMOSTAT COVER
JEV 0317245
75-75112
replaces:
JEV 0337486
SIE 18-1243
FITS V4/V6 CROSSFLOW
A09
A09
THERMOSTAT COVER
75-75004
replaces:
JEV 0338632
THERMOSTAT PLUG
75-75003
replaces:
JEV 0332944
60 DEGREE V4, V6
A09
A09
PAGE 199
(A) COOLING
VALVE
JOHNSON/EVINRUDE
(A) COOLING
THERMOSTAT SEAL
(PACK OF 5)
26-26701
replaces:
THERMOSTAT SEAL
JEV 0332130
75-75111
replaces:
JEV 0339299
FICHT THERMOSTAT 99-04
A10
Thermostat Seals & Gaskets
THERMOSTAT GASKET
(PACK OF 5)
27-02206
replaces:
JEV 0329830
A10
THERMOSTAT GASKET
(PACK OF 5)
SIE 18-1202
PACK OF 5
A10
75-01961
replaces:
A10
THERMOSTAT GASKET
JEV 0310058
V4/V6 LOOP CHARGE
FITS 434841 T-STAT
SIE 18-0182
A10
27-08518
replaces:
A10
THERMOSTAT GASKET
27-00946
replaces:
JEV 0339044
JEV 0313416
FOR 60 DEGREE V4/V6
THERMOSTAT
FOR USE WITH # 396987
THERMOSTAT. FOR 3 CYL ENGINES
A10
PAGE 200
27-00424
replaces:
JEV 0330273
SIE 18-1221
THERMOSTAT GASKET
JEV 0321932
SIE 18-0675
3 CYL (56 CU. IN)
PACK OF 5
THERMOSTAT CUP
27-00760
replaces:
SIE 18-0929
A10
JOHNSON/EVINRUDE
27-00949
replaces:
JEV 0321184
THERMOSTAT COVER
GASKET
SIE 18-2546
FOR V4 CROSSFLOW
A10
27-01665
replaces:
JEV 0318917
A10
THERMOSTAT COVER
GASKET
SIE 18-0397
26-01960
replaces:
JEV 0332108
3 CYL (56 CU. IN)
A10
GROMMET
26-02651
replaces:
JEV 0320880
JEV 0321692
FITS V6 CROSSFLOW
FITS V4 CROSSFLOW
SIE 18-1219
SIE 18-2391
A10
THERMOSTAT SEAL
27-00777
replaces:
SIE 18-2548
A10
GROMMET
JEV 0332369
SIE 18-0977
FITS V6 CROSSFLOW
THERMOSTAT GASKET
27-00952
replaces:
26-08622
replaces:
JEV 0335981
SIE 18-1507
FITS 60° EAGLE & FICHT EFI V4 90115 HP; V6 150-175 HP
A10
A10
O-RING (PACK OF 5)
25-25955
replaces:
JEV 0765563
SIE 18-7143
A10
PAGE 201
(A) COOLING
THERMOSTAT COVER
GASKET
JOHNSON/EVINRUDE
(A) COOLING
O-RING
25-00227
replaces:
O-RING
JEV 0310327
JEV 0331188
SIE 18-7173
SIE 18-7143
FITS VARIOUS THERMOSTAT
HOUSINGS
A10
A10
STARBOARD CYLINDER
HEAD HOSE
32-32400
replaces:
JEV 0340975
PORT CYLINDER HEAD
HOSE
SIE 18-70936
27-00776
JEV 0317227
SIE 18-2938
A13
Exhaust Gaskets
O-RING (PACK OF 5)
JEV 0340976
FOR V4 CROSSFLOW, CYLINDER
HEAD PORT
A11
Water Hoses
replaces:
32-32401
replaces:
SIE 18-70937
FOR V4 CROSSFLOW, CYLINDER
HEAD STARBOARD
EXHAUST GASKET
25-02440
replaces:
A11
Water Hoses
EXHAUST COVER
GASKET
27-27141
replaces:
JEV 0318156
SIE 18-0955
A13
Exhaust Gaskets
25-02109
replaces:
JEV 3852565
SIE 18-7420
PACK OF 5
A13
Exhaust Gaskets
PAGE 202
JOHNSON/EVINRUDE
PAGE 203
JOHNSON/EVINRUDE
(B) ENGINE
POWERHEAD BEARING KIT
POWERHEAD BEARING SET (3 CYL)
replaces:
replaces:
31-03172
JEV
31-03175
JEV
B01
Bearing Kits
FOR SOME 2 CYL. JOHNSON/EVINRUDE™.
HAVE EVERYTHING YOU NEED IN ONE
SPOT
B01
Bearing Kits
FOR SOME LATER MODEL 3 CYL.
MANUFACTURED IN A CAGED-STYLE
TO IMPROVE INSTALLATION & REDUCE
FRICTION
COMPONENT
31-01988
31-02763
31-02766
31-02769
31-02778
31-02779
DESCRIPTION
Lower Crank Bearing
Caged Needle Bearing
Rod Bearing
Split Sleeve Bearing
Upper Main Bearing
Wrist Pin Bearing
QTY
1
1
2
1
1
2
31-03178
B01
Bearing Kits
COMPONENT
31-02763
31-02765
31-02769
31-02779-CG
31-02803
PAGE 204
replaces:
31-03179
FOR SOME V4 JOHNSON/EVINRUDE™. USE
ONE KIT TO DO IT ALL
DESCRIPTION
31-01988
31-02763
31-02766
31-02769
31-02778
31-02779
DESCRIPTION
Lower Crank Bearing
Rod Bearing
Upper Main Bearing
Wrist Pin Bearing
QTY
1
2
3
2
1
3
JEV
Rod Bearing
Caged Wrist Pin Bearing
Ball Bearing
COMPONENT
QTY
1
4
1
4
1
B01
Bearing Kits
COMPONENT
31-02764
31-02765
31-02770
31-02779-CG
31-02803
replaces:
JEV
FOR SOME V4 JOHNSON/EVINRUDE™.
MAKE IT SIMPLE. BUY THE KIT
DESCRIPTION
Needle Bearing
Rod Bearing
Ball Bearing
QTY
1
4
1
4
1
JOHNSON/EVINRUDE
31-03180
B01
Bearing Kits
31-02768
31-02770
31-02780
31-02806
replaces:
31-03181
JEV
FOR SOME V4 LOOPER JOHNSON/
EVINRUDE. ONE KIT DOES IT ALL!
COMPONENT
DESCRIPTION
Rod Bearing
Wrist Pin Bearing
Ball Bearing
QTY
4
1
4
1
31-03182
B01
Bearing Kits
COMPONENT
31-02764
31-02768
31-02770
31-02780
31-02806
replaces:
FOR SOME V6 JOHNSON/EVINRUDE™. GET
THE COMPLETE KIT TO MAKE YOUR JOB
EASIER
COMPONENT
31-02764
31-02765
31-02770
31-02779-CG
31-02803
31-03183
FOR SOME V6 LOOPER JOHNSON/EVINRUDE™.
PRODUCED WITH PREMIUM COMPONENTS TO
HAVE THE JOB RIGHT THE FIRST TIME
DESCRIPTION
B01
Bearing Kits
replaces:
JEV
DESCRIPTION
QTY
2
6
2
6
1
Needle Bearing
Rod Bearing
Ball Bearing
JEV
Needle Bearing
Rod Bearing
Wrist Pin Bearing
Ball Bearing
(B) ENGINE
QTY
2
6
2
6
1
B01
Bearing Kits
COMPONENT
31-02764
31-02768
31-02770
31-02780
31-02806
replaces:
JEV
FOR SOME V8 JOHNSON/EVINRUDE™.
WRIST PIN BEARINGS MAY NOW COME IN
THE EASIER-TO-INSTALL CAGE-STYLE!
DESCRIPTION
Needle Bearing
Rod Bearing
Wrist Pin Bearing
Ball Bearing
QTY
3
8
3
8
1
PAGE 205
JOHNSON/EVINRUDE
(B) ENGINE
UPPER CRANK BEARING
31-02748
replaces:
UPPER MAIN BEARING
JEV 0386481
JEV 0390900
FITS 2CYL 25/25
COMMERCIAL/30/35 HP
INCLUDES S. S. AND VITON SEAL.
FITS 2 & 3CYL ENGINES
SIE 18-1392
SIE 18-1372
B02
Bearings
UPPER MAIN BEARING
31-02778
replaces:
B02
Bearings
BEARING
JEV 0436752
FITS 40/48/50/60/70 HP &
40/45/55/65 COMMERCIAL
ENGINES
FOR V6 19 SPLINE REAR CARRIER
1996 & UP -- 1.250 X 1.625
B02
Bearings
B02
Bearings
31-07635
replaces:
BEARING
31-08700
replaces:
JEV 0386473
JEV 0386014
FOR LOWER GEARCASE
FOR 9.9-15 HP
SIE 18-1296
B02
Bearings
BEARING
31-07633
replaces:
JEV 0398529
SIE 18-1373
BEARING
31-02757
replaces:
31-08761
replaces:
JEV 0390635
B02
Bearings
BEARING
31-31200
replaces:
JEV 0385822
FITS V4, V6, V8 LOOPER AND
CROSSFLOW
B02
Bearings
PAGE 206
B02
Bearings
JOHNSON/EVINRUDE
PAGE 207
JOHNSON/EVINRUDE
(B) ENGINE
LOWER CRANK
BEARING
31-01988
replaces:
CRANK SHAFT BEARING
JEV 0377139
JEV 0330854
USED IN 40-50 HP AS UPPER MAIN.
ALSO USED AS LOWER MAIN IN
SEVERAL APPS FROM 10-150 HP
FOR 2 CYL. 18-35 HP
SIE 18-1154
SIE 18-1391
B02
Bearings
BALL BEARING
31-02803
replaces:
B02
Bearings
BALL BEARING
JEV 0390641
SOME 50 TO 70 HP AS UPPER &
LOWER
FITS MOST V6 LOWER MAINS FROM
135 HP & UP
SIE 18-1396
B02
Bearings
31-07629
replaces:
JEV 0433503
B02
Bearings
CAGED NEEDLE
BEARING
SIE 18-1299
31-02764
B02
Bearings
ROD BEARING
31-02765
replaces:
JEV 5007190
JEV 0387787
FOR V4/V6/V8 CROSSFLOW,
LOOPER & 60° MOTORS
FOR V4-V6 CROSSFLOW 60°
SIE 18-1353
B02
Bearings
PAGE 208
JEV 0378252
FOR OLDER V6 135-200 HP. USED
WITH 31-88903 SPLIT-SLEEVE
B02
Bearings
replaces:
31-02763
replaces:
SIE 18-1352
FOR V4 & V6 60° ENGINES
NEEDLE BEARING
31-02806
replaces:
JEV 0385503
SIE 18-1395
BALL BEARING
31-02747
replaces:
SIE 18-1361
B02
Bearings
JOHNSON/EVINRUDE
31-02766
replaces:
ROD BEARING
JEV 0437088
JEV 0396041
FOR 2 & 3 CYL.(OLD # 388344)
FOR V4, V6, V8 & 90° LOOPER
SIE 18-1378
SIE 18-1360
B02
Bearings
CAGED BEARING
31-02798
replaces:
B02
Bearings
BEARING
JEV 0348495
B02
Bearings
B02
Bearings
31-02779
replaces:
WRIST PIN BEARING
31-02780
replaces:
JEV 0395627
JEV 0434844
FOR ALL 3/4” PINS.
FOR V4, V6, V8 & 90° LOOPER.
SIE 18-1374
SIE 18-1376
B02
Bearings
SPLIT SLEEVE BEARING
31-31261
replaces:
JEV 0389613
SIE 18-1394
WRIST PIN BEARING
31-02768
replaces:
31-02769
replaces:
B02
Bearings
SPLIT SLEEVE BEARING
31-02770
replaces:
JEV 0310433
JEV 0352960
FOR OLDER V6 135-200 HP. USED
WITH 31-67445 CENTER MAIN
BEARING
FOR V4/V6/V8
SIE 18-1362
B02
Bearings
SIE 18-1377
B02
Bearings
PAGE 209
(B) ENGINE
ROD BEARING
JOHNSON/EVINRUDE
(B) ENGINE
LOOSE NEEDLES (18 PER
PACK)
29-01160
replaces:
CRANKSHAFT SEAL KIT
JEV 0764103
JEV
FOR ROD BEARINGS 2, 3, 4, 6 CYL
FOR 2 CYL (1972-1992) ; 3 CYL
(1986-1992)
B02
Bearings
B03
Crankshaft Seals
SIE 18-4040
CRANKSHAFT SEAL KIT
CRANKSHAFT SEAL KIT
CRANKSHAFT SEAL KIT
PAGE 210
26-26613
replaces:
26-26614
replaces:
CRANKSHAFT SEAL KIT
26-26615
replaces:
JEV
JEV
FOR 3 AND 3 CYL (1993-2003)
FOR V4/V6 CROSS (1979-1991)
B03
Crankshaft Seals
B03
Crankshaft Seals
26-26616
replaces:
CRANKSHAFT SEAL KIT
26-26617
replaces:
JEV
JEV
FOR V4 CROSS (1992-1998)
FOR V4 LOOPER (1989-2003) ; V6
LOOPER (1989-1991)
B03
Crankshaft Seals
B03
Crankshaft Seals
26-26618
replaces:
CRANKSHAFT SEAL KIT
26-26619
replaces:
JEV
JEV
FOR V6 LOOPER (1992-1993)
FOR V4/V6 60° ENGINE
B03
Crankshaft Seals
B03
Crankshaft Seals
JOHNSON/EVINRUDE
26-01580
replaces:
OIL SEAL
JEV 0398051
B03
Crankshaft Seals
B03
Crankshaft Seals
26-01774
replaces:
SIE 18-2093
O-RING (PACK OF 5)
JEV 0303360
B03
Crankshaft Seals
B03
Crankshaft Seals
25-00225
replaces:
SIE 18-7117
O-RING
25-00256
replaces:
JEV 0310414
JEV 0308876
B03
Crankshaft Seals
B03
Crankshaft Seals
SIE 18-7167
WASHER
25-00248-50
replaces:
JEV 0328603
SIE 18-8350
O-RING
replaces:
JEV 0321504
SIE 18-8351
OIL SEAL
26-01639
11-03669
replaces:
(B) ENGINE
UPPER CRANKSHAFT
SEAL
SIE 18-7123
WASHER
10-03674
replaces:
JEV 0328703
JEV 0306358
B03
Crankshaft Seals
B04
Engine Seals & Gaskets
PAGE 211
JOHNSON/EVINRUDE
(B) ENGINE
EXHAUST GASKET
(PACK OF 2)
27-00755
replaces:
JEV 0323459
SILENCER GASKET
(PACK OF 5)
SIE 18-0999-9
MANIFOLD GASKET
(PACK OF 2)
PACK OF 5
B04
B04
27-00930
replaces:
JEV 0319174
LEAF PLATE GASKET
(PACK OF 5)
27-00950
JEV 0324323
B04
LEAF PLATE GASKET
(PACK OF 5)
SIE 18-0106
JEV 0322858
SIE 18-2547
PACK OF 2
B04
PAGE 212
JEV 0321907
PACK OF 5
B04
27-00972
27-00971
replaces:
SIE 18-0991
EXHAUST MANIFOLD COVER
GASKET
PACK OF 2
replaces:
JEV 0326260
PACK OF 5
B04
replaces:
27-00934
replaces:
SIE 18-2862
MANIFOLD TO CRANKCASE.
PACK OF 2
WATER COVER GASKET
(PACK OF 2)
JEV 0323338
PACK OF 2
SIE 18-2867
EXHAUST GASKET
(PACK OF 2)
27-00768
replaces:
B04
EXHAUST GASKET
(PACK OF 2)
27-00994
replaces:
JEV 0319348
SIE 18-2904
PACK OF 2
B04
JOHNSON/EVINRUDE
27-00997
replaces:
JEV 0325721
PACK GASKET (PACK
OF 2)
SIE 18-2907
27-01719
JEV 0325260
B04
LEAF PLATE GASKET
(PACK OF 2)
SIE 18-0122
27-01973
JEV 0328626
REED BLOCK GASKET
(PACK OF 5)
SIE 18-0144
27-01979
JEV 0331532
SIE 18-0161
PACK OF 5
B04
JEV 0332266
B04
B04
replaces:
27-01974
replaces:
SIE 18-0130
PACK OF 5
INTAKE GASKET (PACK
OF 5)
JEV 0318924
B04
B04
replaces:
27-01722
replaces:
SIE 18-0959
PACK OF 5
REED BOX GASKET
(PACK OF 5)
JEV 0321497
PACK OF 2
B04
replaces:
replaces:
SIE 18-0983
PACK OF 2
LEAF PLATE GASKET
(PACK OF 5)
27-01708
(B) ENGINE
EXHAUST GASKET
(PACK OF 2)
EXHAUST GASKET
(PACK OF 2)
27-02209
replaces:
JEV 0326264
SIE 18-0126
PACK OF 2
B04
PAGE 213
JOHNSON/EVINRUDE
(B) ENGINE
EXHAUST GASKET
(PACK OF 2)
27-27124
replaces:
JEV 0304762
WATER GASKET (PACK
OF 2)
SIE 18-2871
PACK OF 2
B04
27-27145
replaces:
JEV 0318925
B04
CARBURETOR GASKET
(PACK OF 2)
SIE 18-2853
27-27150
JEV 0329319
B04
CARBURETOR GASKET
(PACK OF 5)
27-27766
JEV 0321479
SIE 18-0981
PACK OF 2
B04
PAGE 214
JEV 0327707
FOR V4-V6
PACK OF 5
B04
replaces:
27-27201
replaces:
SIE 18-0134
PACK OF 5
LEAF PLATE GASKET
(PACK OF 2)
JEV 0318932
PACK OF 2
B04
replaces:
27-27146
replaces:
SIE 18-0961
PACK OF 2
FUEL PUMP GASKET
(PACK OF 5)
JEV 0317951
SIE 18-0953
PACK OF 2
EXHAUST GASKET
(PACK OF 2)
27-27139
replaces:
B04
BYPASS GASKET (PACK
OF 5)
27-27767
replaces:
JEV 0319661
SIE 18-0971
PACK OF 5
B04
JOHNSON/EVINRUDE
27-00751
replaces:
AIR SILENCER GASKET
JEV 0321722
B04
B04
27-00761
replaces:
SIE 18-0985
WATER JACKET GASKET
JEV 0318609
FOR BIG BORE, V6 CROSSFLOW
FOR V4/V6 LOOP CHARGE
ENGINES
SIE 18-2543
B04
B04
27-00771
replaces:
JEV 0328618
INNER MANIFOLD
GASKET
27-00775
replaces:
JEV 0331016
27-00774
replaces:
JEV 0326926
SIE 18-1212
B04
SILENCER GASKET
27-00769
replaces:
JEV 0393561
SIE 18-0927
BASE GASKET
replaces:
JEV 0331916
SIE 18-2913
EXHAUST COVER
GASKET
27-00756
(B) ENGINE
EXHAUST COVER
GASKET
B04
BY-PASS COVER
GASKET
27-00909
replaces:
JEV 0307133
SIE 18-2876
FOR V4 & V6 CROSSFLOW
B04
B04
PAGE 215
JOHNSON/EVINRUDE
(B) ENGINE
POWER HEAD GASKET
27-00919
replaces:
JEV 0313763
POWERHEAD BASE
GASKET
SIE 18-2865
ADAPTER TO POWERHEAD GASKET.
FOR V4 CROSSFLOW, 1978-1996
B04
27-00939
replaces:
JEV 0327674
B04
INTAKE MANIFOLD
GASKET
SIE 18-3899
27-00973
replaces:
BASE GASKET
JEV 0323469
27-01599
JEV 0325211
SIE 18-0120
B04
PAGE 216
27-01490
replaces:
JEV 0318373
SIE 18-0957
FOR V4 CROSSFLOW, 1973-1977
B04
replaces:
JEV 0329718
B04
SIE 18-0102
WATER PASSAGE
GASKET
27-00969
replaces:
SIE 18-0148
B04
EXHAUST MANIFOLD
GASKET
JEV 0342513
SIE 18-2864
FOR 3 CYL
CYLINDER HEAD COVER
GASKET
27-00936
replaces:
B04
POWERHEAD BASE
GASKET
27-01631
replaces:
JEV 0328590
SIE 18-0138
B04
JOHNSON/EVINRUDE
AIR BOX GASKET
27-01632
replaces:
AIR COVER GASKET
JEV 0330698
B04
B04
27-01706
replaces:
SIE 18-0157
INTAKE MANIFOLD
GASKET
SIE 18-0159
27-01712
replaces:
27-01707
replaces:
JEV 0317504
SIE 18-0963
B04
B04
RELIEF GASKET
27-01714
replaces:
JEV 0351018
JEV 0329826
B04
B04
SIE 18-0128
POWERHEAD BASE
GASKET
replaces:
JEV 0329975
JEV 0330909
POWERHEAD BASE
GASKET
27-01704
(B) ENGINE
POWERHEAD BASE
GASKET
27-01723
replaces:
JEV 0324717
SIE 18-0112
B04
SIE 18-0851
INTAKE MANIFOLD
GASKET
27-01972
replaces:
JEV 0777417
SIE 18-0142
B04
PAGE 217
JOHNSON/EVINRUDE
(B) ENGINE
AIR BOX COVER
GASKET
INTAKE COVER TO BASE
GASKET
27-01976
replaces:
RECTIFIER GASKET
JEV 0331101
JEV 0330412
B04
B04
27-01983
replaces:
JEV 0331585
SIE 18-0155
POWERHEAD BASE
GASKET
27-11004
replaces:
JEV 0335419
27-02205
replaces:
JEV 0329828
SIE 18-1205
B04
POWERHEAD BASE
GASKET
27-01978
replaces:
B04
POWERHEAD BASE
GASKET
27-11010
replaces:
JEV 0344386
HOUSING TO POWERHEAD GASKET
B04
B04
STARBOARD SIDE
INTAKE GASKET
27-11006
replaces:
JEV 0336227
SIE 18-0693
FOR STARBOARD INTAKE. FOR 60°
V6 EAGLE & FICHT FFI; 150-175 HP,
1991 AND UP
B04
PAGE 218
PORT SIDE INTAKE
GASKET
27-11005
replaces:
JEV 0336226
SIE 18-0694
FOR PORT INTAKE. FOR 60° V6
EAGLE & FICHT FFI; 150-175 HP,
1991 AND UP
B04
JOHNSON/EVINRUDE
27-11008
replaces:
JEV 0336389
PORT SIDE INTAKE
GASKET
SIE 18-0695
FOR PORT INTAKE. FOR 60° V4
EAGLE & FICHT FFI; 90-115 HP, 1995
AND UP
B04
27-27125
replaces:
JEV 0304784
B04
EXHAUST MANIFOLD
GASKET
SIE 18-1229
BASE GASKET
27-27128
replaces:
27-27127
replaces:
JEV 0311364
SIE 18-1228
B04
EXHAUST PLATE GASKET
JEV 0336388
SIE 18-0696
FOR STARBOARD INTAKE. FOR 60°
V4 EAGLE & FICHT FFI; 90-115 HP,
1995 AND UP
BYPASS COVER GASKET
27-11007
replaces:
B04
AIR SILENCER GASKET
27-27130
replaces:
JEV 0311365
JEV 0314115
B04
B04
27-27131
replaces:
JEV 0314322
SIE 18-0935
B04
SIE 18-0933
INTAKE MANIFOLD
GASKET
27-27134
replaces:
JEV 0315578
SIE 18-0424
B04
PAGE 219
(B) ENGINE
STARBOARD SIDE
INTAKE GASKET
JOHNSON/EVINRUDE
(B) ENGINE
GASKET
27-27132
replaces:
JEV 0314964
INNER EXHAUST COVER
GASKET
B04
B04
27-27136
replaces:
CARBURETOR GASKET
JEV 0317305
B04
B04
27-27138
replaces:
SIE 18-0951
WATER JACKET GASKET
JEV 0318335
B04
B04
27-27143
replaces:
JEV 0323214
SIE 18-2550
POWERHEAD TO BASE GASKET,
BIG BORE
B04
PAGE 220
27-27142
replaces:
JEV 0317914
SIE 18-2866
POWERHEAD BASE
GASKET
27-27137
replaces:
JEV 0315869
SIE 18-1224
EXHAUST COVER
GASKET
JEV 0315868
SIE 18-1218
CYLINDER TO CRANKCASE, PORT
OUTER EXHAUST COVER
GASKET
27-27135
replaces:
SIE 18-2873
ADAPTOR HOUSING
GASKET
27-27144
replaces:
JEV 0351019
SIE 18-0136
B04
JOHNSON/EVINRUDE
AIR BOX COVER
GASKET
SILENCER GASKET
AIR SILENCER GASKET
27-27147
replaces:
BYPASS COVER GASKET
27-27148
(B) ENGINE
WATER JACKET GASKET
replaces:
JEV 0318962
JEV 0319332
B04
B04
27-27149
replaces:
SIE 18-0967
GASKET
27-27151
replaces:
JEV 0320679
JEV 0330078
B04
B04
27-27152
replaces:
GASKET
27-27153
replaces:
JEV 0330910
JEV 0331099
B04
B04
27-27154
replaces:
EXHAUST PLATE GASKET
27-27160
replaces:
JEV 0331696
JEV 0317955
B04
B04
SIE 18-0117
PAGE 221
JOHNSON/EVINRUDE
(B) ENGINE
WATER JACKET COVER
GASKET
27-27200
replaces:
JEV 0315538
WATER JACKET COVER
GASKET
SIE 18-0941
WATER JACKET COVER GASKET.
FOR 9.9-15 HP
B04
27-27405
replaces:
JEV 0330621
B04
EXHAUST COVER
GASKET
SIE 18-2852
27-27554
replaces:
HEAD COVER GASKET
SIE 18-2544
ADAPTER TO MIDSECTION.
B04
B04
27-27764
JEV 0321183
SIE 18-0979
B04
PAGE 222
27-27763
replaces:
JEV 0321028
SIE 18-0930
replaces:
JEV 0321435
B04
JEV 0508991
AIR SILENCER GASKET
27-27534
replaces:
SIE 18-2549
B04
BASE GASKET
JEV 0329920
SIE 18-2905
WATER JACKET COVER GASKET, 2
CYL.40-60 HP.
BASE GASKET
27-27202
replaces:
EXHAUST COVER
GASKET
27-27968
replaces:
JEV 0321182
SIE 18-2545
B04
JOHNSON/EVINRUDE
26-02741
replaces:
INTAKE SEAL
JEV 0335403
JEV 0335404
FOR 60° V6 EAGLE; 150-175 HP,
1991-2000
FOR 60° V6 EAGLE; 150-175 HP,
1991-2000
B04
B04
SIE 18-1285
INTAKE SEAL
26-08623
replaces:
INTAKE SEAL
JEV 0335819
FOR 60° V4 EAGLE; 150-175 HP,
1991-2000
FOR 60° V4 EAGLE; 150-175 HP,
1991-2000
SIE 18-1284
B04
26-00069
replaces:
B04
PROPSHAFT SEAL
26-01043
replaces:
JEV 0318972
JEV 0302564
B04
B04
SIE 18-2025
SEAL
26-08624
replaces:
JEV 0335818
SIE 18-1283
DRIVESHAFT SEAL
26-02742
replaces:
26-01044
replaces:
JEV 0305987
SIE 18-2018
B04
SIE 18-2021
DRIVESHAFT /
PROPSHAFT SEAL
26-01046
replaces:
JEV 0313284
SIE 18-2005
B04
PAGE 223
(B) ENGINE
INTAKE SEAL
JOHNSON/EVINRUDE
(B) ENGINE
DRIVESHAFT /
PROPSHAFT SEAL
26-01584
replaces:
OIL SEAL
JEV 0303345
JEV 0321831
B04
B04
SIE 18-2022
O-RING (PACK OF 5)
25-00202
replaces:
SIE 18-0542
O-RING (PACK OF 5)
25-00250
replaces:
JEV 0302540
JEV 0305123
PACK OF 5
FOR V4 CROSSFLOW
PACK OF 5
SIE 18-7114
SIE 18-7133
B04
B04
O-RING (PACK OF 5)
26-01770
replaces:
25-00436
replaces:
O-RING (PACK OF 5)
JEV 0303191
25-25813
replaces:
JEV 0338513
SIE 18-7413
PACK OF 5
B04
B04
O-RING (PACK OF 5)
PAGE 224
25-25903
replaces:
O-RING (PACK OF 5)
26-26704
replaces:
JEV 0765577
JEV 0335524
B04
B04
JOHNSON/EVINRUDE
replaces:
POWER HEAD GASKET SET
JEV 0438904
SIE 18-4321
FOR 60 HP 1989-97; 65
COMMERCIAL 1987-95; 70 HP
1986-97
B05
Powerhead Gasket Sets
POWERHEAD GASKET
KIT
27-03196
replaces:
JEV 0439084
SIE 18-4302
FOR 60 HP 1989-97; 65
COMMERCIAL, 1984-86; 70 HP,
1977-85
B05
GASKET KIT
27-00498
replaces:
JEV 0391988
SIE 18-4304-1
27-00496
replaces:
JEV 0433941
SIE 18-4307
FOR 20 HP 1981-94/ 25 HP COMMERCIAL 1982-95; 25 HP 1979-02 EXCEPT
DR, DE, D T MODELS; 30 HP 1984-02; 35 HP 1979-83 (87 B SUFFIX MODELS
ONLY) USES HEAD GASKET # 27-00765 (433941)
B05
POWERHEAD GASKET SET
27-01890
replaces:
JEV 0439085
SIE 18-4303-1
FOR 150 HP 1979-90; 150 HP 1991 (MODELS TL, TX, CX, ST, SL) ; 155
COMMERCIAL 1984-92; 175 HP 1977-83; 185 HP 1984-85; 200 HP 1976-83;
235 HP 1978-79; 2500CC 1988; 2.5L SEA DRIVE 1984-85
FOR 80 HP JET 1991-96; 85 HP 1979-80; 88, 112 HP 1987-95; 90 HP 1981-95;
100 HP 1979-95; 115 HP 1977-95; 135 HP 1973-76; 140 HP 1977-84; 1600 CC
1988; 1.6L SEA DRIVE 1983-90. USES HEAD GASKET 27-00966 (318358)
B05
B05
PAGE 225
(B) ENGINE
27-02195
GASKET KIT
JOHNSON/EVINRUDE
(B) ENGINE
GASKET KIT
27-02687
replaces:
JEV 0432570
SIE 18-4322
GASKET KIT
27-02688
replaces:
JEV 0436891
SIE 18-4323
FOR 120-140 HP 1988-93; 130 HP 1994-02; 2.0L SEA DRIVE 1988-1990
FOR 185 HP 1990-93; 200 HP 1988-93; 225 HP 1988-93; 3.0L SEA DRIVE 198890. USES HEAD GASKET 27-02199
B05
B05
GASKET KIT
27-03195
replaces:
JEV 0439083
SIE 18-4305
27-03501
replaces:
JEV 0437155
SIE 18-4406
FOR 40, 40 COMMERCIAL, 45 COMMERCIAL, 48, 50, 55 & 60 HP
THIS KIT DOES NOT USE TRADITIONAL HEAD GASKETS.
FOR 150-175 HP 1991-99
B05
B05
PAGE 226
JOHNSON/EVINRUDE
27-08651
replaces:
JEV 0396750
SIE 18-4310
GASKET KIT
27-08652
replaces:
JEV 0398172
SIE 18-4308
FOR 120-140 HP, 1985-1987
FOR 200/225 HP, 1986-1987 & 2.7 SEA DRIVES, 1987
B05
B05
GASKET KIT
27-08654
replaces:
JEV 0398693
(B) ENGINE
GASKET KIT
GASKET KIT
27-08655
replaces:
JEV 0434381
SIE 18-4309
FOR 250, 275 & 3.6L 1988-93; 300 HP 1993-94 (BIG BORE ENGINES) USES
HEAD GASKET 27-13260
FOR 175 HP 1986-92; 235 HP 1980-85; 2.6L SEA DRIVE 1982-86. USES HEAD
GASKET 27-13211
B05
B05
PAGE 227
JOHNSON/EVINRUDE
(B) ENGINE
27-08692
replaces:
JEV 0394546
SIE 18-4306
27-08693
FOR 9.9 & 15 HP 1975-92; 10 COMMERCIAL 1989-90; 14 HP 1988-90. THIS KIT
USES # 330818 HEAD GASKET
FOR 200 & 225 HP, 1994-2002
B05
B05
27-08694
replaces:
JEV 0439202
SIE 18-4420
SIE 18-4428
27-08695
FOR 150-175 HP V6 60 ° FICHT FFI 1997-98
FOR 90-115 HP, 1995 & UP
B05
B05
PAGE 228
replaces:
JEV 0437725
replaces:
JEV 0439559
SIE 18-4402
JOHNSON/EVINRUDE
replaces:
JEV 5000400
27-08696
(B) ENGINE
GASKET SET
27-11011
replaces:
JEV 0436358
FOR 90-115 HP FFI, 1998 & UP
FOR 9.9-15 HP 1993-UP. THIS KIT USES # 338222 HEAD GASKET
B05
B05
GASKET KIT
27-13300
replaces:
JEV 0390700
SIE 18-4324
GASKET SET
27-27010
replaces:
JEV 0787131
FOR 40 HP COMMERCIAL 1987-91. USES HEAD GASKET 27-13132 (307069)
B05
B05
PAGE 229
JOHNSON/EVINRUDE
27-00765
replaces:
HEAD GASKET
JEV 0203130
USED IN KIT 27-00496 (433941)
FOR 3 HP, 1957-68; 4 HP, 1969-80;
4.5 HP, 1980
SIE 18-3841-2
B06
Head Gaskets
HEAD GASKET
27-00958
replaces:
B06
Head Gaskets
HEAD GASKET
JEV 0318358
FOR 55/60/65/65
COMMERCIAL/70/75 HP USED IN
KIT 27-03196 (439084)
USED IN KIT 27-01890 (439085)
CAN ALSO BE USED W/27-03197
(388602)
SIE 18-2956
B06
Head Gaskets
27-00967
replaces:
B06
Head Gaskets
HEAD GASKET
JEV 0335359
USED IN KIT 27-00498
USED IN KIT 27-03195 (439083)
SIE 18-3802
B06
Head Gaskets
27-01107
replaces:
B06
Head Gaskets
HEAD GASKET
27-02197
replaces:
JEV 0329836
JEV 0340115
FOR 40 HP 1960-80; 40 HP
COMMERCIAL 1981-90. USED IN KIT
27-02195 (438904)
USED IN 27-02687. FOR 120-140 HP
1988-93; 130 HP 1994-02; 2.0L SEA
DRIVE 1988-90
SIE 18-3836
B06
Head Gaskets
PAGE 230
27-01105
replaces:
JEV 0766779
SIE 18-2964
HEAD GASKET
27-00966
replaces:
JEV 0313413
SIE 18-2960
HEAD GASKET
27-00780
replaces:
JEV 0765012
SIE 18-3803
(B) ENGINE
(B) ENGINE
HEAD GASKET
SIE 18-3866
B06
Head Gaskets
JOHNSON/EVINRUDE
PAGE 231
JOHNSON/EVINRUDE
(B) ENGINE
HEAD GASKET
27-02199
replaces:
HEAD GASKET
JEV 0333670
JEV 0338222
FOR 9.9-15 HP 1993-UP. USED IN KIT
27-11011 (436358)
B06
Head Gaskets
B06
Head Gaskets
SIE 18-3839
HEAD GASKET
27-02961
replaces:
HEAD GASKET
JEV 0309612
FOR 5 HP 1965-68/5.5 HP 1959-64/6
HP 1965-79
FOR 9.5 HP, 1964-1973
SIE 18-2950
B06
Head Gaskets
27-08662
replaces:
B06
Head Gaskets
HEAD GASKET
JEV 0345257
SIE 18-0492
B06
Head Gaskets
27-13132
replaces:
B06
Head Gaskets
HEAD GASKET
27-13133
replaces:
JEV 0307069
JEV 0315539
FOR 40 HP, 1960-1980; 40 HP
COMMERCIAL., 1981-1990. USED IN
KIT 27-13300 (390700)
FOR 50 HP, 1971-1975
SIE 18-2957
B06
Head Gaskets
PAGE 232
27-08806
replaces:
JEV 0329786
SIE 18-3840
HEAD GASKET
27-03500
replaces:
JEV 0329103
SIE 18-2961
HEAD GASKET
27-02584
replaces:
SIE 18-2958
B06
Head Gaskets
JOHNSON/EVINRUDE
27-13137
replaces:
HEAD GASKET
JEV 0322332
JEV 0330818
FOR 18 HP, 1959-1973; 25 HP,
1969-1976
USED IN KIT 27-08692 (394546)
SIE 18-2962
SIE 18-2963
B06
Head Gaskets
HEAD GASKET
27-13210
replaces:
B06
Head Gaskets
HEAD GASKET
JEV 0335361
FOR 5/6/8 HP, 1984-1995; 6.5
COMMERCIAL., 1989-1990 ; 7.5 HP,
1980-1993
SIE 18-3801
B06
Head Gaskets
27-13237
replaces:
B06
Head Gaskets
HEAD GASKET
27-13240
replaces:
JEV 0331211
JEV 0328623
USED IN 27-08651. FOR 120-140 HP,
1985-87; 1.8L SEA DRIVE, 1987
SIE 18-3838
SIE 18-3837
B06
Head Gaskets
HEAD GASKET
27-13211
replaces:
JEV 0325273
SIE 18-3800
HEAD GASKET
27-13138
replaces:
27-13260
replaces:
JEV 0340116
SIE 18-3885
B06
Head Gaskets
B06
Head Gaskets
HEAD GASKET
27-27123
replaces:
JEV 0304720
SIE 18-2951
B06
Head Gaskets
PAGE 233
(B) ENGINE
HEAD GASKET
JOHNSON/EVINRUDE
(B) ENGINE
HEAD GASKET
27-27126
replaces:
HEAD GASKET
JEV 0306048
JEV 0313782
B06
Head Gaskets
B06
Head Gaskets
SIE 18-2959
HEAD GASKET
ROD BOLT (PACK OF 2)
27-27899
replaces:
SIE 18-2884
HEAD GASKET
JEV 0346007
B06
Head Gaskets
B06
Head Gaskets
10-03050
replaces:
SIE 18-0491
10-03051
replaces:
JEV 0330081
JEV 0308186
FOR SOME V6 CROSSFLOW, V4 &
V6 LOOPER
PACK OF 2
FOR SOME 2 CYL, 3 CYL, V4 & V6
CROSSFLOW
PACK OF 2
SIE 18-4075
B07
Connecting Rods & Bolts
10-10900
replaces:
JEV 0346044
3/8”. FITS 4 TO 8 CYLINDER LOOPER
ENGINES, AS WELL AS 3.3L FICHT
PACK OF 2
B07
PAGE 234
27-27953
replaces:
JEV 0115496
SIE 18-4076
27-27129
replaces:
B07
WRIST PIN
775-02213
replaces:
JEV 0327861
SIE 18-4280
B07
JOHNSON/EVINRUDE
775-02894
replaces:
CONNECTING ROD
JEV 0322188
JEV 0394462
SIE 18-4282
SIE 18-1752
FOR 3 CYL 70 HP 1986-UP, 3 CYL 60
HP 1989-UP. CASTING # 329837
B07
CONNECTING ROD
93-08723
replaces:
B07
CONNECTING ROD
JEV 0394488
FOR 2 CYL 25-35 1985-UP; 3 CYL 70
1974-85; 3 CYL 60 TO 1988
FOR V4/V6/V8 LOOPER ENGINES.
PRIOR TO 1993
SIE 18-4148-1
35-35150
replaces:
B07
OIL FILTER
35-35152
replaces:
JEV 0763364
JEV 0778886
B08
Oil Filters & Accessories
B08
SIE 18-7903
OIL FILTER
93-13272
replaces:
JEV 0433509
B07
OIL FILTER
93-08719
replaces:
35-35153
replaces:
SIE 18-7896
OIL FILTER
35-35154
replaces:
JEV 0778887
JEV 0778888
B08
B08
SIE 18-7897
SIE 18-7895
PAGE 235
(B) ENGINE
WRIST PIN
JOHNSON/EVINRUDE
PAGE 236
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 237
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 238
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 239
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 240
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 241
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 242
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 243
JOHNSON/EVINRUDE
(D) GEARCASE
PAGE 244
JOHNSON/EVINRUDE
BEARING CARRIER
SHIFTER HOUSING
43-43901
replaces:
BEARING CARRIER
replaces:
JEV 5001587
JEV 0436832
D01
Gearcase Components
D01
Gearcase Components
93-93150
replaces:
BEARING CARRIER
93-93151
replaces:
JEV 0393300
JEV 0387374
USED WITH PROP SHAFT # 395209.
OLD OEM: 393300
USED WITH PROP SHAFT # 982416
D01
Gearcase Components
D01
Gearcase Components
43-43902
replaces:
BEARING HOUSING KIT
93-03970
replaces:
JEV 5001601
JEV
D01
Gearcase Components
D01
Gearcase Components
COMPONENT
BEARING HOUSING PIN
AND SPRING
93-03969
(D) GEARCASE
BEARING CARRIER
93-03960
replaces:
JEV 0391365
COMPONENT OF 93-03970,
COMPLETE HOUSING KIT. INCLUDES
31-02754 (389039) BEARING
PRESSED IN
93-03960
93-03961
93-03963
93-03964
93-08505
93-08608
93-08626
93-08628
DESCRIPTION
Bearing Housing Pin and
Spring
Shifter Lever
Spring
Detente Ball
Detente
Shifter Arm Pin
Cradle Shift
Shifter Shaft
QTY
1
1
1
1
1
1
1
1
D01
Gearcase Components
PAGE 245
JOHNSON/EVINRUDE
(D) GEARCASE
SHAFT & BEARING HOUSING KIT
HOUSING & BEARING
ASSEMBLY
93-08501
replaces:
JEV 0389455
SIE 18-3767
COMPLETE HOUSING KIT.
ASSEMBLY INCLUDES BEARING
(389039) AND PIN (331880)
D01
Gearcase Components
93-03712
replaces:
BEARING HOUSING
ASSEMBLY
JEV
D01
Gearcase Components
COMPONENT
93-03713
93-08501
93-08609
93-08626
93-08627
93-08628
DESCRIPTION
Detent Shifter
Housing & Bearing Assembly
Shift Lever Pin
Cradle Shift
Shifter Lever
Shifter Shaft
BEARING HOUSING &
SEAL
93-08507
replaces:
JEV 0435274
QTY
1
1
1
1
1
1
93-08506
replaces:
D01
Gearcase Components
SHIFTER DETENT
JEV 0439476
93-93919
replaces:
JEV 0347377
SIE 18-4807
FOR V4 AND V6 GEARCASES
D01
Gearcase Components
D01
Gearcase Components
DETENTE
93-08505
replaces:
93-08627
replaces:
JEV 0915954
JEV 0322938
COMPLETE HOUSING KIT
COMPLETE HOUSING KIT. FOR V4,
V6, COBRA & STRINGER MOUNT
GEARCASES
SIE 18-1731
D01
Gearcase Components
PAGE 246
SHIFTER LEVER
SIE 18-3762
D01
Gearcase Components
JOHNSON/EVINRUDE
93-93451
replaces:
SHIFTER LEVER
JEV 0332492
93-03961
replaces:
JEV 0324037
D01
Gearcase Components
SHIFTER SHAFT
SHIFT SHAFT
DETENTE BALL
93-93452
replaces:
D01
Gearcase Components
SHIFT SHAFT
93-93920
replaces:
JEV 0332503
JEV 0348483
D01
Gearcase Components
D01
Gearcase Components
93-93921
replaces:
DETENTE BALL
43-02750
replaces:
JEV 0348484
JEV 0316506
D01
Gearcase Components
D01
Gearcase Components
93-03964
replaces:
SIE 18-2243
SPRING
93-03963
replaces:
JEV 0327345
JEV 0911961
D01
Gearcase Components
D01
Gearcase Components
PAGE 247
(D) GEARCASE
SHIFT LEVER
JOHNSON/EVINRUDE
(D) GEARCASE
SPRING
93-08629
replaces:
SHIFTER SPRING
JEV 0911962
93-93453
replaces:
JEV 0332484
SIE 18-1502
D01
Gearcase Components
D01
Gearcase Components
SPRING
93-03675
replaces:
CRADLE SHIFT
JEV 0308590
93-08626
replaces:
JEV 0334163
SIE 18-3766
D01
Gearcase Components
SHIFT CRADLE
RETAINER
PAGE 248
93-08724
replaces:
D01
Gearcase Components
RETAINING TAB
93-08612
replaces:
JEV 0332507
JEV 0333957
D01
Gearcase Components
D01
Gearcase Components
93-93454
replaces:
SIE 18-1343
PIN
93-08606
replaces:
JEV 0332495
JEV 0305070
D01
Gearcase Components
D01
Gearcase Components
JOHNSON/EVINRUDE
93-08607
replaces:
SHIFTER ARM PIN
JEV 0331880
JEV 0320145
D01
Gearcase Components
D01
Gearcase Components
SIE 18-3765
SHIFT LEVER PIN
93-08609
replaces:
PIN
93-08788
replaces:
JEV 0328825
JEV 0311538
ROLL PIN FOR DRIVE SHAFTS
D01
Gearcase Components
D01
Gearcase Components
SIE 18-3764
ALIGNMENT PIN
93-08608
replaces:
93-93460
replaces:
RETAINING WEDGE
JEV 0331095
93-08738
replaces:
JEV 0349001
FOR NEW STYLE CARRIERS
D01
Gearcase Components
SHIFT SHAFT GROMMET
26-26152
replaces:
D01
Gearcase Components
SHIFT ROD COVER
93-08504
replaces:
JEV 0321452
JEV 0435482
D01
Gearcase Components
D01
Gearcase Components
PAGE 249
(D) GEARCASE
HOUSING PIN
JOHNSON/EVINRUDE
(D) GEARCASE
COVER & BUSHING
ASSEMBLY
93-08722
replaces:
SHIFT ROD SPACER
JEV 0434588
JEV 0321122
D01
Gearcase Components
D01
Gearcase Components
SIE 18-1729
SHIFT ROD CONNECTOR
RETAINING RING
BEARING CARRIER
RETAINING RING
PAGE 250
93-93101
replaces:
93-93450
replaces:
SIE 18-4822
RETAINING RING
24-24101
replaces:
JEV 0332508
JEV 0338778
D01
Gearcase Components
D01
Gearcase Components
93-03968
replaces:
RETAINING RING
93-08639
replaces:
JEV 0313445
JEV 0340493
D01
Gearcase Components
D01
Gearcase Components
93-93251
replaces:
SIE 18-1707
RETAINER PLATE
93-03967
replaces:
JEV 0321171
JEV 0314732
D01
Gearcase Components
D01
Gearcase Components
JOHNSON/EVINRUDE
93-03991
replaces:
WASHER (PACK OF 5)
JEV 0313453
13-13102
(D) GEARCASE
RETAINER PLATE
replaces:
JEV 0328702
PACK OF 5
D01
Gearcase Components
WASHER
WASHER
12-00778
replaces:
D01
Gearcase Components
replaces:
JEV 0321738
JEV 0305981
D01
Gearcase Components
D01
Gearcase Components
93-08635
replaces:
BEARING AND SEAL KIT
31-08347
replaces:
JEV 0328743
JEV
FOR RETAINING TAB
INCLUDES BEARINGS, THRUST
WASHERS & SEALS
D01
Gearcase Components
D02
Bearing Kits
SIE 18-1726
COMPONENT
THRUST WASHER
12-12121
WASHER
93-08637
replaces:
JEV 0336565
FOR REVERSE GEAR
10-08610
26-03951
31-02752
31-02754
31-02762
31-02771
31-02773
31-02774
31-07633
43-02787
43-08345
DESCRIPTION
Pinion Nut
Combined Lower Seal Kit
Lower Gearcase Bearing
Prop Shaft Bearing
Pinion Bearing
Bearing
Clutch Dog Spring
Shim Kit
QTY
1
1
1
1
1
1
1
1
1
1
1
D01
Gearcase Components
PAGE 251
JOHNSON/EVINRUDE
(D) GEARCASE
COMPONENT
10-08610
26-03951
31-02126
31-02752
31-02754
31-02762
31-02771
31-02773
31-02774
43-02787
43-08345
10-08681
26-07400
31-02751
31-02752
31-02755
31-02756
31-02760
31-02761
31-02775
31-02776
43-02785
43-02786
43-08346
PAGE 252
31-08351
replaces:
JEV
JEV
FOR V6 SMALL REVERSE
FOR V4 CROSSFLOW
D02
Bearing Kits
D02
Bearing Kits
DESCRIPTION
Pinion Nut
Carrier Bearing
Prop Shaft Bearing
Pinion Bearing
Clutch Dog Spring
Shim Kit
COMPONENT
31-08349
replaces:
QTY
1
1
1
1
1
1
1
1
1
1
1
31-08353
COMPONENT
10-08610
26-03951
31-02752
31-02753
31-02754
31-02758
31-02771
31-02773
31-02777
43-02787
43-08345
DESCRIPTION
Pinion Nut
Prop Shaft Bearing
Lower Gearcase Carrier
Bearing
Clutch Dog Spring
Shim Kit
replaces:
QTY
1
1
1
1
1
1
1
1
1
1
1
31-08355
replaces:
JEV
JEV
INCLUDES BEARINGS, SEALS, SHIMS,
PINION NUT, CLUTCH SPRING, AND
PIN
CONTAINS FORWARD, PINION, AND
REVERSE
D02
Bearing Kits
D02
Bearing Kits
DESCRIPTION
Pinion Nut
Seal Kit
Clutch Dog Pin
Clutch Dog Spring
Shim Kit
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
10-08657
10-08681
26-00076
31-02751
31-02752
31-02758
31-02771
31-02772
31-02777
43-02787
43-08344
DESCRIPTION
Clutch Dog Pin
Pinion Nut
Lower Gearcase Seal Kit
Bearing
Clutch Dog Spring
Shim Kit
QTY
1
1
1
1
1
1
1
1
1
1
1
JOHNSON/EVINRUDE
31-08357
CARRIER BEARING
replaces:
JEV
JEV 0387247
FOR 2 CYL, 40-60 HP 1978-1988
FOR BEARING CARRIER. ALSO FITS
MANY O/B’S FROM 40 HP-V6
SIE 18-1158
D03
Bearings
D02
Bearing Kits
COMPONENT
10-08681
26-00082
31-02760
31-02761
31-07623
31-07624
31-07631
31-07651
43-02785
43-02786
43-08343
31-02126
replaces:
DESCRIPTION
Pinion Nut
Thrust Bearing
Thrust Bearing
Bearing
Pinion Bearing
Clutch Dog Pin
Clutch Dog Spring
Shim Kit
QTY
1
1
1
1
1
1
1
1
1
1
1
LOWER GEARCASE
BEARING
31-02751
replaces:
JEV 0382343
SIE 18-1356
FOR GIMBAL HOUSING. 215 E & H
& TR/TRS DRIVES
D03
Bearings
LOWER GEARCASE
BEARING
31-02752
replaces:
JEV 0382407
LOWER GEARCASE
BEARING
SIE 18-1351
FOR V4 CROSSFLOW & V4 60 °
SMALL FOOT 90-115 HP 1995-UP
D03
Bearings
31-02756
replaces:
JEV 0432264
SIE 18-1369
FOR LOWER GEAR CASE
FORWARD GEAR IN 40-50 HP 2 & 3
CYL ENGINES
D03
Bearings
JEV 0384195
SIE 18-1357
FOR PROP SHAFT ON 3 CYL, V4
AND V6
LOWER GEARCASE
BEARING
31-02753
replaces:
D03
Bearings
LOWER GEARCASE
CARRIER BEARING
31-02758
replaces:
JEV 0379504
SIE 18-1350
FOR LOWER GEAR CASE, 3 CYL
AND V4
D03
Bearings
PAGE 253
(D) GEARCASE
JOHNSON/EVINRUDE
(D) GEARCASE
LOWER GEARCASE
BEARING
31-02760
replaces:
JEV 0386764
LOWER GEARCASE
BEARING
SIE 18-1354
FOR LOWER GEARCASE
D03
Bearings
31-02799
replaces:
D03
Bearings
BEARING
JEV 0437288
FITS 2CYL ENGINES
FOR PROP SHAFT ON SOME 20-40
HP ENGINES, 1985-1997
D03
Bearings
D03
Bearings
31-07625
replaces:
JEV 0391471
FORWARD GEAR
BEARING
D03
Bearings
BEARING
PAGE 254
31-07609
replaces:
JEV 0393896
SIE 18-1393
NEEDLE BEARING
JEV 0386765
SIE 18-1355
FOR LOWER GEAR CASE ON 2 CYL
40-50 HP
BEARING
31-02761
replaces:
31-07634
replaces:
31-07632
replaces:
JEV 0386186
D03
Bearings
PINION BEARING
31-07651
replaces:
JEV 0434467
JEV 0386766
CARRIER AFT BEARING
FOR 2CYL 40-50 HP 1979-80
D03
Bearings
D03
Bearings
JOHNSON/EVINRUDE
31-01868
replaces:
JEV 0388027
LOWER GEARCASE
BEARING
FOR 40-50 HP 2 CYL, LOWER GEAR
CASE
D03
Bearings
31-02771
replaces:
JEV 0382408
D03
Bearings
LOWER GEARCASE
BEARING
SIE 18-1366
31-02773
JEV 0387656
D03
Bearings
LOWER GEARCASE
BEARING
SIE 18-1365
31-02775
JEV 0397537
SIE 18-1363
FOR 40-50 HP 2 CYL
D03
Bearings
JEV 0389042
COMMONLY USED WITH 12-02793
(327669) THRUST WASHER. FOR
FORWARD GEAR
D03
Bearings
replaces:
31-02774
replaces:
SIE 18-1370
(327656) THRUST WASHER
LOWER GEARCASE
BEARING
JEV 0385068
FOR UPPER DRIVE SHAFT
D03
Bearings
replaces:
31-02772
replaces:
SIE 18-1367
FORWARD GEAR
LOWER GEARCASE
BEARING
JEV 0398901
SIE 18-1368
FOR 20, 35 HP 1985-1997
LOWER GEARCASE
BEARING
31-02755
replaces:
D03
Bearings
LOWER GEARCASE
BEARING
31-02776
replaces:
JEV 0397538
SIE 18-1364
FOR 40-50 HP 2 CYL, LOWER GEAR
CASE
D03
Bearings
PAGE 255
(D) GEARCASE
THRUST BEARING
JOHNSON/EVINRUDE
(D) GEARCASE
LOWER GEARCASE
BEARING
31-02777
replaces:
THRUST BEARING
JEV 0385043
31-07623
replaces:
JEV 0386719
SIE 18-1371
FORWARD GEAR
D03
Bearings
D03
Bearings
THRUST BEARING
31-07624
replaces:
BEARING
JEV 0389297
31-01901
replaces:
JEV 0983891
SIE 18-1161
PINION GEAR BEARING FOR UPPER
COBRA DRIVE
D03
Bearings
TAPERED ROLLER
BEARING
31-07630
replaces:
JEV 0375761
D03
Bearings
CAGED WRIST PIN
BEARING
FOR ALL 3/4” PINS.
MANUFACTURED IN A CAGEDSTYLE TO IMPROVE INSTALLATION &
REDUCE FRICTION
D03
Bearings
31-02780-CG
replaces:
JEV 0434844
SIE 18-1376
JEV 0395627
SIE 18-1374
FOR STRINGER MOUNT DRIVES
CAGED WRIST PIN
BEARING
31-02779-CG
replaces:
D03
Bearings
WRIST PIN
CONVERSION KIT
31-31520
replaces:
JEV
FOR V4, V6, V8 & 90° LOOPER.
MANUFACTURED IN A CAGEDSTYLE TO IMPROVE INSTALLATION &
REDUCE FRICTION
D03
Bearings
PAGE 256
D03
Bearings
JOHNSON/EVINRUDE
45-09960
replaces:
DRIVESHAFT
JEV 0438398
JEV 5007672
FOR 2 CYL 40, 48, 50 HP.
STANDARD 15” LENGTH
FOR V4 CROSSFLOW 85-140 HP.
ALSO FOR V6, LENGTH IS 20”
SIE 18-2329
D04
Shafts
DRIVESHAFT
45-02865
replaces:
D04
Shafts
DRIVESHAFT
JEV 5000624
FOR V4 SMALL FOOT AND V6, FOR
60° BIG FOOT, 90-140 HP. LENGTH
IS 20”
FOR 60° BIG FOOT, 90-140 HP.
LENGTH IS 25”
SIE 18-2330
D04
Shafts
45-09940
replaces:
D04
Shafts
20” DRIVESHAFT
45-09950
replaces:
JEV 0433067
JEV 0438399
FOR 2 CYL 40, 48, 50 HP, 19891992. LENGTH OF 20”
FOR 2 CYL 40, 48, 50 HP, 19932993. LENGTH OF 20”
SIE 18-1721
SIE 18-1722
D04
Shafts
DRIVESHAFT
45-02866
replaces:
JEV 5000615
SIE 18-2327
20” DRIVESHAFT
45-02862
replaces:
45-26157
replaces:
D04
Shafts
DRIVESHAFT
45-26158
replaces:
JEV 0396812
JEV 0437376
FOR 2 CYL 40-60 HP. LONG
LENGTH
FOR 3 CYL 50-75 HP
D04
Shafts
D04
Shafts
PAGE 257
(D) GEARCASE
15” DRIVESHAFT
JOHNSON/EVINRUDE
(D) GEARCASE
DRIVESHAFT
45-02859
replaces:
UPPER ASSEMBLY SHAFT
JEV 5000626
JEV 5000618
FOR V4 CROSSFLOW 85-140 HP;
AND FOR V6, LENGTH IS 25”
FOR V4 CROSSFLOW 85-140 HP,
1992 AND UP (OLD STYLE) ALSO
FOR V6
SIE 18-2328
SIE 18-2325
D04
Shafts
UPPER ASSEMBLY SHAFT
45-45800
replaces:
D04
Shafts
DRIVESHAFT
JEV 0345905
FOR V4 CROSSFLOW 85-140 HP,
1992 AND UP (NEW STYLE)
FOR V4 AND V6 GEAR CASES
RANGING FROM 90 HP TO 225 HP
SIE 18-9219
45-02932
replaces:
D04
Shafts
DRIVESHAFT
45-02933
replaces:
JEV 0346005
JEV 0346006
FOR V6, 250 HP, 1991-1995 AND
1997
FOR V4 CROSSFLOW 85-140 HP
SIE 18-2279
SIE 18-2277
D04
Shafts
LOWER DRIVESHAFT
45-02931
replaces:
JEV 5000618
D04
Shafts
DRIVESHAFT
45-02858
replaces:
45-09040
replaces:
JEV 0346004
SIE 18-1723
D04
Shafts
LOWER DRIVE SHAFT
45-45011
replaces:
JEV 0347371
FOR V4 SMALL FOOT
D04
Shafts
PAGE 258
D04
Shafts
JOHNSON/EVINRUDE
44-01995
replaces:
PROP SHAFT
JEV 0386659
FOR LATE MODEL 800 SERIES
DRIVES. OLD OEM: 391472
FOR 2 CYL 40-60 HP
SIE 18-1725
D04
Shafts
44-02934
replaces:
D04
Shafts
PROP SHAFT
JEV 0439185
FOR 2 CYL 40, 48, 50 HP
FOR 3 CYL 50-75 HP
SIE 18-2250
D04
Shafts
44-02936
replaces:
D04
Shafts
PROP SHAFT
44-02937
replaces:
JEV 5004765
JEV 0436888
FOR 60° BIG FOOT, 90-140 HP.
ALSO FOR V6, DIAMETER IS 1 1/4”
SIE 18-2251
SIE 18-2252
D04
Shafts
PROP SHAFT
44-02935
replaces:
JEV 0439138
SIE 18-2288
PROP SHAFT
replaces:
JEV 0395209
SIE 18-2187
PROP SHAFT
44-02746
(D) GEARCASE
PROP SHAFT
44-09030
replaces:
D04
Shafts
PROP SHAFT
44-13059
replaces:
JEV 5006310
JEV 0982416
FOR V4 SMALL FOOT
FOR EARLY MODEL 800 DRIVES
SIE 18-1725
D04
Shafts
SIE 18-2188
D04
Shafts
PAGE 259
JOHNSON/EVINRUDE
(D) GEARCASE
RETAINER
93-08638
replaces:
JEV 0338504
DRIVESHAFT BEARING
HOUSING
SIE 18-1732
93-26154
replaces:
JEV 0385087
FOR DRIVE SHAFTS (NEXT PAGE)
D04
Shafts
D04
Shafts
SHIFT ROD
PINION NUT
CLUTCH DOG SPRING
93-08511
replaces:
93-93103
replaces:
JEV 0329864
JEV 0335510
D04
Shafts
D04
Shafts
10-08681
replaces:
CLUTCH DOG PIN
43-02785
replaces:
JEV 0313339
JEV 0320310
D05
Gear Components
D05
Gear Components
43-02786
replaces:
JEV 0320311
SIE 18-2398
D05
Gear Components
PAGE 260
25” SHIFT ROD
CLUTCH DOG SPRING
43-02787
replaces:
JEV 0324369
SIE 18-2399
FOR V4 1969-UP; V6 1976-UP AND
V8 1985-UP
D05
Gear Components
JOHNSON/EVINRUDE
43-02732
replaces:
CLUTCH DOG
JEV 0323664
CONTAINS BEARINGS, SEALS,
SHIMS, GEARS AND CLUTCH DOG
FOR V4
SIE 18-2220
D06
Gear Sets
43-02734
replaces:
CLUTCH DOG
43-02735
replaces:
JEV 0319895
D06
Gear Sets
D06
Gear Sets
43-02736
replaces:
JEV 0332491
SIE 18-2308
D06
Gear Sets
CLUTCH DOG
D06
Gear Sets
JEV 0337774
SIE 18-2216
CLUTCH DOG
replaces:
JEV 0318303
SIE 18-2209
CLUTCH DOG
43-02733
43-08502
replaces:
JEV 0337020
SIE 18-1290
D06
Gear Sets
(D) GEARCASE
CLUTCH DOG
SIE 18-2287
NOTICE: ABOUT EMP GEARS
EMP gears are specifically
designed as matched sets
(Fwd, Pin & Rev) to ensure and
elevate the level of quality.
Therefore, to avoid gearcase
damage, these specially
engineered gears SHOULD
NOT be used
to mate
with other
vendors
or used
parts.
PAGE 261
JOHNSON/EVINRUDE
(D) GEARCASE
COMPLETE GEAR SET
WITH GASKETS
COMPONENT
10-08610
10-08657
26-03951
31-02752
31-02754
31-02762
31-02771
31-02773
31-02774
31-07633
43-02734
43-02787
43-02903-96
43-08345
43-08348
JEV
43-08350
replaces:
JEV
FOR LARGE REVERSE. INCLUDES
FORWARD, PINION, REVERSE,
CLUTCH DOG, BEARINGS, SHIMS &
SEAL KIT
FOR SMALL REVERSE INCLUDES
FORWARD, PINION, REVERSE,
CLUTCH DOG, BEARINGS, SHIMS &
SEAL KIT
D06
Gear Sets
D06
Gear Sets
DESCRIPTION
Pinion Nut
Clutch Dog Pin
Prop Shaft Bearing
Pinion Bearing
Bearing
Clutch Dog
Clutch Dog Spring
Large Reverse Gear Set
Shim Kit
COMPLETE GEAR SET
WITH GASKETS
COMPLETE GEAR SET
WITH GASKETS
replaces:
QTY
COMPONENT
1
1
1
1
1
1
1
1
1
1
1
1
1
1
10-08610
10-08657
26-03951
31-02126
31-02752
31-02754
31-02762
31-02771
31-02773
31-02774
43-02734
43-02787
43-02903-09
43-08345
43-08352
DESCRIPTION
Pinion Nut
Clutch Dog Pin
Carrier Bearing
Prop Shaft Bearing
Pinion Bearing
Clutch Dog
Clutch Dog Spring
Small Reverse Gear Set
Shim Kit
COMPLETE GEAR SET
WITH GASKETS
replaces:
JEV
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
1
43-08354
replaces:
JEV
INCLUDES FORWARD, PINION &
REVERSE GEARS, CLUTCH DOG,
SEALS, SHIMS, PINION NUT, CLUTCH
SPRING & PIN
D06
Gear Sets
COMPONENT
10-08610
26-03951
31-02752
31-02753
31-02754
31-02758
31-02771
31-02773
31-02777
43-02733
43-02787
43-02904-08
43-08345
PAGE 262
DESCRIPTION
Pinion Nut
Prop Shaft Bearing
Bearing
Clutch Dog
Clutch Dog Spring
Gear Set
Shim Kit
D06
Gear Sets
QTY
COMPONENT
1
1
1
1
1
1
1
1
1
1
1
1
1
10-08681
26-07400
31-02751
31-02752
31-02755
31-02756
31-02760
31-02761
31-02775
31-02776
43-02736
43-02785
43-02786
43-02905-06
43-08346
DESCRIPTION
Pinion Nut
Seal Kit
Bearing
Bearing
Bearing
Bearing
Bearing
Bearing
Bearing
Bearing
Clutch Dog
Clutch Dog Pin
Clutch Dog Spring
Gear Set (F/P/R)
Shim Kit
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
JOHNSON/EVINRUDE
COMPONENT
10-08657
10-08681
26-00076
31-02751
31-02752
31-02758
31-02771
31-02772
31-02777
43-02732
43-02787
43-02902-07
43-08344
43-08356
JEV
43-08358
replaces:
JEV
FOR 3 CYL, 50-75 HP 1979-2003
KIT INCLUDES FORWARD, PINION
AND REVERSE GEARS, CLUTCH
DOG, BEARINGS, SEALS, O-RINGS
& SHIMS
D06
Gear Sets
D06
Gear Sets
DESCRIPTION
Clutch Dog Pin
Pinion Nut
Bearing
Clutch Dog
Clutch Dog Spring
Gear Set (F/P/R)
Shim Kit
COMPLETE GEAR SET
WITH GASKETS
COMPLETE GEAR SET
WITH GASKETS
replaces:
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
43-48702
DESCRIPTION
Pinion Nut
Thrust Bearing
Thrust Bearing
Bearing
Bearing
Clutch Dog
Clutch Dog Pin
Clutch Dog Spring
Matched Gear Set (F/P/R)
Shim Kit
10-08681
26-00082
31-02760
31-02761
31-07623
31-07624
31-07631
31-07631
43-02735
43-02785
43-02786
43-02901
43-08343
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPLETE GEAR KIT
replaces:
JEV
0435123/0336574/0337774
INCLUDES GEARS, CLUTCH DOG,
BEARINGS, SEALS & SHIMS
D06
Gear Sets
COMPONENT
10-08610
26-03951
31-02752
31-02754
31-02762
31-02771
31-02773
31-02774
31-07633
43-02787
43-08345
43-08713
DESCRIPTION
Pinion Nut
Prop Shaft Bearing
Pinion Bearing
Bearing
Clutch Dog Spring
Shim Kit
Complete Gear Set
QTY
1
1
1
1
1
1
1
1
1
1
1
1
43-04352
D06
Gear Sets
COMPONENT
31-08351
43-42904
replaces:
JEV
CONTAINS ALL OF THE COMPONENTS IN
OUR 31-08351 AND 43-42904, COMBINED
INTO ONE CONVENIENT KIT!
DESCRIPTION
Bearing and Seal Kit
Complete Gear Set
QTY
1
1
PAGE 263
(D) GEARCASE
COMPLETE GEAR SET
WITH GASKETS
JOHNSON/EVINRUDE
(D) GEARCASE
COMPLETE GEAR SET
WITH CLUTCH
43-02900
replaces:
JEV
MATCHED GEAR SET
(F/P/R)
SIE 18-1293
INCLUDES FORWARD, PINION AND
REVERSE GEARS
D06
Gear Sets
43-02902-07
replaces:
JEV 0397338/0318304
LARGE REVERSE GEAR
SET
D06
Gear Sets
SMALL REVERSE GEAR
SET
43-02903-09
replaces:
JEV 5004938/0910994
CONTAINS FORWARD, PINION,
REVERSE AND CLUTCH DOG
FORWARD, PINION AND SMALL
REVERSE. FOR USE WITH 1 3/16”
PROP SHAFT
D06
Gear Sets
D06
Gear Sets
43-02903-96
replaces:
GEAR SET
43-02904-08
replaces:
JEV 5004216/0336561
JEV 0436746/0345992
FORWARD, PINION & LARGE
REVERSE. FOR USE WITH 1 1/4”
PROP SHAFT
AND 60° V4 SMALL FOOT
D06
Gear Sets
D06
Gear Sets
SIE 18-1292
GEAR SET (F/P/R)
JEV 0433570
SIE 18-2289
CONTAINS FOLLOWING OEM
REPLACEMENTS: 337020, 392475,
328313, 327655 & 319635
GEAR SET (F/P/R)
43-02901
replaces:
43-02905-06
replaces:
JEV 0397627/0332489
FORWARD & PIN GEAR
SET
43-03702
replaces:
JEV 5004941
CONTAINS FORWARD, PINION
AND REVERSE. REPLACES OEM
397627+332489
D06
Gear Sets
PAGE 264
D06
Gear Sets
JOHNSON/EVINRUDE
43-08701
replaces:
COMPLETE GEAR SET
JEV 0435123
43-08713
replaces:
JEV
SIE 18-1291
12:27 RATIO FOR 60° BIG FOOT 90140 HP. INCLUDES CLUTCH DOG
D06
Gear Sets
COMPLETE GEAR SET
43-42901
replaces:
D06
Gear Sets
COMPLETE GEAR SET
JEV 0433570/0319895
JEV
0436746/0345992/0323664
INCLUDES FORWARD, PINION &
REVERSE GEARS, AND CLUTCH
DOG
SIE 18-2221
AND 60° V4 SMALL FOOT. INCLUDES
CLUTCH DOG
D06
Gear Sets
D06
Gear Sets
COMPLETE GEAR SET
43-43009
replaces:
COMPLETE GEAR SET
43-43096
replaces:
JEV
5004216/0910994/0337774
JEV
5004216/0336561/0337774
FOR GEAR CASE WITH SMALL
REVERSE GEAR. INCLUDES:
FORWARD, PINION, REVERSE AND
CLUTCH DOG
FOR GEARCASES W/ LARGE
REVERSE GEAR. INCLUDES
FORWARD, PINION, REVERSE &
CLUTCH DOG
SIE 18-2217
SIE 18-2290
D06
Gear Sets
GEAR SET (F/P/R)
43-42904
replaces:
43-43100
replaces:
D06
Gear Sets
GEAR SET (F/P/R)
43-43110
replaces:
JEV
JEV
CONTAINS FOLLOWING OEM
REPLACEMENTS: 392475, 328313,
327655 & 319635
12:27 RATIO. INCLUDES FORWARD,
PINION AND REVERSE GEARS
D06
Gear Sets
D06
Gear Sets
PAGE 265
(D) GEARCASE
GEAR SET
JOHNSON/EVINRUDE
(D) GEARCASE
COMPLETE GEAR SET
43-43731
replaces:
GEAR SET (F P R)
JEV 0435088/0437297
43-43900
replaces:
JEV 5001582
REPLACES 500491+437297.14.26
RATIO. USED WITH PROP SHAFT 4413059 (982416)
D06
Gear Sets
D06
Gear Sets
GEAR SET (F & P)
43-43912
replaces:
COMPLETE GEAR SET
JEV 0398522
43-48354
replaces:
JEV
0397627/0332489/0332491
SIE 18-2315
FOR 2 CYL 40, 48, 50 HP. INCLUDES
CLUTCH DOG
COMPLETE GEAR SET
D06
Gear Sets
D06
Gear Sets
43-48356
EMP gears are
specifically designed
as matched sets (Fwd,
Pin & Rev) to ensure
and elevate the level
of quality. Therefore,
to avoid gearcase
damage individual
gears should only be
paired with other NEW
EMP gears.
replaces:
JEV
0397338/0318304/0318303
SIE 18-2210
FOR 3 CYL 50-75 HP. INCLUDES
CLUTCH DOG
D06
Gear Sets
PINION GEAR
43-08707
replaces:
REVERSE GEAR
43-08708
replaces:
JEV 0328313
JEV 0327655
D06
Gear Sets
D06
Gear Sets
SIE 18-1288
PAGE 266
NOTICE
ABOUT
PURCHASING
INDIVIDUAL
GEARS:
SIE 18-1289
JOHNSON/EVINRUDE
43-43910
REVERSE GEAR
replaces:
JEV 0318353
D06
Gear Sets
D06
Gear Sets
43-08796
PROP NUT KIT
replaces:
D07
Prop Components
COMPONENT
11-00582
11-02502
18-18001
11-02672
replaces:
JEV 0319635
JEV 0175266
D06
Gear Sets
D07
Prop Components
SIE 18-3715
PROP NUT KIT
11-01573
replaces:
JEV 0392475
SIE 18-1287
BUSHING
43-43911
PROP NUT KIT
replaces:
JEV 0175269
11-01574
FOR 9.9-15 HP
DESCRIPTION
Prop Nut
Spacer
Cotter Pin (Pack of 5)
(D) GEARCASE
FORWARD GEAR &
BUSHING
replaces:
JEV 0175268
SIE 18-3717
D07
Prop Components
QTY
1
1
1
COMPONENT
11-00580
11-00581
11-01390
DESCRIPTION
QTY
Prop Nut
Cotter Pin
Prop Spacer
1
1
1
PAGE 267
JOHNSON/EVINRUDE
(D) GEARCASE
PROP NUT KIT
11-01576
D07
Prop Components
COMPONENT
11-00577
11-01386
18-00578
PROP NUT & WASHER KIT
replaces:
JEV 0175267
SIE 18-3716
INCLUDES SPACER
DESCRIPTION
QTY
Prop Nut
Prop Spacer
Cotter Pin
1
1
1
11-11001
11-00574
11-01286
11-02671
18-18002
PAGE 268
replaces:
JEV 0386866
D07
Prop Components
CONTAINS ALL COMPONENTS OF 1101576, ALONG WITH THE 11-01389 THRUST
WASHER
COMPONENT
11-00577
11-01386
11-01389
18-00578
replaces:
JEV 0434153
11-11002
D07
Prop Components
DESCRIPTION
Prop Nut Spacer
Prop Thrust Washer
Prop Nut Kit
Cotter Pin (Pack of 5)
DESCRIPTION
Prop Nut
Prop Spacer
Prop Washer
Cotter Pin
QTY
1
1
1
1
D07
Prop Components
COMPONENT
11-11000
QTY
1
1
1
1
COMPONENT
11-00577
11-01286
11-01386
18-00578
replaces:
JEV 0384573
SIE 18-3753
INCLUDES SPACER AND WASHER
DESCRIPTION
Prop Nut
Prop Thrust Washer
Prop Spacer
Cotter Pin
QTY
1
1
1
1
JOHNSON/EVINRUDE
18-18011
replaces:
JEV 0306376
COTTER PIN (PACK OF
5)
D07
Prop Components
COTTER PIN (PACK OF
5)
18-18001
replaces:
JEV 0328522
COTTER PIN (PACK OF
5)
11-00581
18-00584
replaces:
JEV 0552906
D07
Prop Components
COTTER PIN
11-00583
replaces:
JEV 0320785
JEV 0302804
D07
Prop Components
D07
Prop Components
SIE 18-3743
COTTER PIN
JEV 0306394
SIE 18-3744
D07
Prop Components
replaces:
replaces:
D07
Prop Components
PACK OF 5
COTTER PIN
18-18002
18-00578
replaces:
(D) GEARCASE
COTTER PIN (PACK OF
10)
SIE 18-3740
COTTER PIN
11-00573
replaces:
JEV 0314502
JEV 0309955
STAINLESS STEEL
MADE OF STAINLESS STEEL
SIE 18-3742
D07
Prop Components
SIE 18-3741
D07
Prop Components
PAGE 269
JOHNSON/EVINRUDE
(D) GEARCASE
PROP NUT
11-00577
replaces:
PROP NUT
JEV 0314503
JEV 0319891
D07
Prop Components
D07
Prop Components
SIE 18-3705
PROP NUT
11-00582
replaces:
SIE 18-3707
PROP NUT SPACER
JEV 0320570
D07
Prop Components
D07
Prop Components
11-01386
replaces:
SIE 18-4231
PROP SPACER
PAGE 270
11-01390
replaces:
JEV 0315810
JEV 0323943
D07
Prop Components
D07
Prop Components
SIE 18-4228
SPACER
11-00574
replaces:
JEV 0318971
SIE 18-3706
PROP SPACER
11-00580
replaces:
11-02502
replaces:
SIE 18-4232
THRUST BUSHING
11-03053
replaces:
JEV 0323942
JEV 0127084
D07
Prop Components
D07
Prop Components
SIE 18-4222
JOHNSON/EVINRUDE
PROP WASHER
11-11100
replaces:
PROP THRUST WASHER
replaces:
JEV 0334590
JEV 0126870
D07
Prop Components
D07
Prop Components
11-01389
replaces:
SIE 18-4223
THRUST WASHER
12-02503
replaces:
JEV 0320305
JEV 0327716
D07
Prop Components
D07
Prop Components
SIE 18-4230
THRUST WASHER
11-01286
12-02504
replaces:
(D) GEARCASE
THRUST BUSHING
THRUST WASHER
JEV 0330441
12-02788
replaces:
JEV 0313447
SIE 18-0193
FOR REVERSE GEAR
D07
Prop Components
THRUST WASHER
12-02789
replaces:
D07
Prop Components
THRUST WASHER
12-02790
replaces:
JEV 0314731
JEV 0317230
FOR 3 CYL, V4 & V6
FOR UPPER DRIVE SHAFT
SIE 18-0195
D07
Prop Components
SIE 18-0194
D07
Prop Components
PAGE 271
JOHNSON/EVINRUDE
(D) GEARCASE
THRUST WASHER
12-02791
replaces:
THRUST WASHER
JEV 0324766
JEV 0327656
FOR FORWARD GEAR
FOR DRIVE SHAFT
SIE 18-0198
SIE 18-0200
D07
Prop Components
THRUST WASHER
12-02793
replaces:
D07
Prop Components
THRUST WASHER
12-02794
replaces:
JEV 0327669
JEV 0332514
FOR V6
FOR 40-50 HP 1989-95, NONCOMMERCIAL MODELS
SIE 18-0199
SIE 18-0196
D07
Prop Components
D07
Prop Components
THRUST WASHER
12-02792
replaces:
12-02796
replaces:
THRUST WASHER
JEV 0333771
12-08636
replaces:
JEV 0323845
SIE 18-0201
FOR 40-50 HP 2 CYL
D07
Prop Components
D07
Prop Components
THRUST WASHER
PAGE 272
12-12000
replaces:
THRUST WASHER
12-12101
replaces:
JEV 0349193
JEV 0397566
D07
Prop Components
D07
Prop Components
JOHNSON/EVINRUDE
ANODE
12-26151
replaces:
THRUST WASHER
JEV 0319684
D07
Prop Components
D07
Prop Components
93-04011
replaces:
ANODE
SIE 18-6095
FOR BEARING CARRIER
D08
Anodes & Trim Tabs
93-93408
replaces:
93-04037
replaces:
JEV 0431708
SIE 18-6024
D08
Anodes & Trim Tabs
ANODE
93-93410
replaces:
JEV 0173029
JEV 0392123
D08
Anodes & Trim Tabs
D08
Anodes & Trim Tabs
SIE 18-6017
TRIM TAB
replaces:
JEV 0320115
JEV 0436745
ANODE
31-01807
93-93104
replaces:
SIE 18-6027
TAB RETAINER
93-08618
replaces:
JEV 0338742
JEV 0352741
D08
Anodes & Trim Tabs
D08
Anodes & Trim Tabs
(D) GEARCASE
THRUST WASHER
PAGE 273
JOHNSON/EVINRUDE
(D) GEARCASE
SCREEN
93-08660
replaces:
WATER SCREEN KIT
JEV 0337778
JEV 0778370
D08
Anodes & Trim Tabs
D08
Anodes & Trim Tabs
SIE 18-1500
SCREEN
WATER SCREEN
DRAIN GASKET (PACK
OF 10)
46-46800
replaces:
93-93105
replaces:
SCREEN
93-93116
replaces:
JEV 0350264
JEV 0350265
D08
Anodes & Trim Tabs
D08
Anodes & Trim Tabs
93-03966
replaces:
SCREEN
93-93102
replaces:
JEV 0323466
JEV 0321123
D08
Anodes & Trim Tabs
D08
Anodes & Trim Tabs
12-02108
replaces:
JEV 0307552
SIE 18-2945
SHIFT ROD GASKET
27-00779
replaces:
JEV 0304764
SIE 18-0882
FOR SHIFT ROD
Also Available
12-02108-50
Drain Screw Gasket 50 Pack
D09
Seals, O-Rings, & Gaskets
PAGE 274
D09
JOHNSON/EVINRUDE
27-00920
replaces:
WATER PUMP GASKET
JEV 0314082
JEV 0303339
SHIFT HOUSING COVER TO GEAR
CASE
FOR BEARING HOUSING
SIE 18-2855
SIE 18-2891
D09
SHIFT ROD COVER
GASKET
27-00975
replaces:
D09
WATER PUMP GASKET
JEV 0324449
FOR SHIFTER HOUSING OF V4 AND
V6 CROSSFLOW AND LOOPER
ENGINES
FOR WEAR PLATE
SIE 18-0108
D09
27-01673
replaces:
JEV 0982132
D09
OUTDRIVE MOUNTING
GASKET SET
SIE 18-2595
26-01765
JEV
D09
D09
replaces:
27-02376
replaces:
SIE 18-3674
SHIFT ROD AND WEAR PLATE
GASKETS IN SET
GROMMET
27-00996
replaces:
JEV 0352165
SIE 18-0110
GASKET
27-00964
replaces:
GROMMET
26-00022
replaces:
JEV 0310597
JEV 0909606
D09
D09
PAGE 275
(D) GEARCASE
SHIFT ROD COVER
GASKET
JOHNSON/EVINRUDE
(D) GEARCASE
LOWER GEARCASE SEAL
KIT
COMPONENT
10-02583
10-02589
25-00063
25-00166
25-00205
25-00209
25-00260
25-00261
25-00786
25-02441
26-00062
26-00074
26-01634
26-01674
26-06013
26-26150
27-00920
26-00076
GEAR HOUSING SEAL
KIT
replaces:
JEV 5000309
SIE 18-2656
D09
D09
FOR 9.9/15 HP 1974-89
QTY
4
2
1
1
1
1
1
1
1
1
1
1
1
4
1
1
1
Bolt
Screw
Seal
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Exhaust Seal
Seal
Seal
Oil Seal
Prop Shaft Seal
26-00078
COMPONENT
12-00778
25-00163
25-00164
25-00165
25-00267
25-01675
26-00067
26-00068
26-00069
27-00957
JEV 0396351
PAGE 276
DESCRIPTION
Screw
Washer
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring (Pack of 5)
Driveshaft Seal
Driveshaft Seal
Seal
Seal
Water Pump Gasket
QTY
1
1
1
1
1
2
2
2
1
2
Washer
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Driveshaft Seal
Driveshaft Seal
Drain Screw Gasket (Pack
of 5)
26-00079
replaces:
JEV 0396352
SIE 18-2657
FOR 25 HP 1984 & 25 COMMERCIAL,
28 HP 1985-89
D09
10-02589
12-00778
25-00029
25-00158
25-00159
25-00162
25-00165
25-00267
25-01076
25-01437
26-00024
26-00028
26-01674
26-08641
27-00979
DESCRIPTION
GEAR HOUSING SEAL
KIT
replaces:
SIE 18-2658
COMPONENT
JEV 0396350
SIE 18-2660
DESCRIPTION
GEAR HOUSING SEAL
KIT
26-00077
replaces:
D09
QTY
2
1
1
1
2
1
2
1
1
2
2
1
3
1
1
COMPONENT
25-00157
25-00165
25-01675
26-00064
26-00065
26-00066
26-00156
26-01674
27-00779
27-00957
27-00974
27-00996
DESCRIPTION
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Propshaft Seal
Driveshaft Seal
Spaghetti Seal 40”
Seal
Shift Rod Gasket
of 5)
Water Pump Gasket
Water Pump Gasket
QTY
1
1
2
2
1
1
1
1
1
2
1
1
JOHNSON/EVINRUDE
26-00082
26-01728
SEAL KIT
replaces:
replaces:
JEV 0396355
JEV
SIE 18-2659
SIE 18-2684
FOR OLDER 10/18/25 HP
D09
COMPONENT
10-02583
10-02589
25-00063
25-00166
25-00204-50
25-00209
25-00287
25-00495
25-00786
25-01923
26-00021
26-00062
26-00074
26-01634
26-01913
26-06013
26-26153
27-00781
27-00920
SEAL KIT
DESCRIPTION
D09
QTY
3
2
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
Bolt
Screw
Seal
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Seal
Propshaft Seal
Exhaust Seal
Seal
Seal
Oil Seal
Prop Shaft Seal
Water Pump Gasket
26-01729
COMPONENT
25-00157
25-00165
25-00267
25-00495
26-00065
26-00156
26-01049
27-00779
27-00957
SIE 18-2686
DESCRIPTION
1
1
1
1
1
1
2
1
2
26-01769
replaces:
JEV
FOR 6 HP
D09
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Propshaft Seal
Shift Rod Gasket
of 5)
QTY
SIE 18-2687
FOR OLDER 28/33/35/40/40C
25-00165
25-00204-50
25-00267
25-00786
26-00068
26-00156
26-01043
26-01046
27-00779
27-00957
DESCRIPTION
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Propshaft Seal
Seal
Shift Rod Gasket
of 5)
GEAR HOUSING SEAL
KIT
replaces:
JEV
COMPONENT
(D) GEARCASE
LOWER GEARCASE SEAL
KIT
D09
QTY
COMPONENT
1
1
1
1
3
1
1
1
1
2
25-00165
25-00248-50
25-00786
26-00156
26-01045
26-01047
27-00957
27-00964
DESCRIPTION
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
of 5)
Water Pump Gasket
QTY
1
1
1
1
1
1
2
1
PAGE 277
JOHNSON/EVINRUDE
(D) GEARCASE
GEAR HOUSING SEAL
KIT
26-01777
COMBINED LOWER
SEAL KIT
replaces:
JEV
26-03951
replaces:
JEV 5006373
SIE 18-2688
SIE 18-2623
D09
D09
FOR 50 HP 1971-74
COMPONENT
25-00150
25-00158
25-00159
25-00165
25-00166
25-00260
25-00261
25-00262
25-00495
26-00027
26-00064
26-00074
27-00920
27-00957
SEAL KIT
DESCRIPTION
QTY
2
1
4
1
1
1
1
1
1
2
2
1
1
2
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Seal
Exhaust Seal
of 5)
26-07400
COMPONENT
10-02583
10-05193
25-00155
25-00166
25-00205
25-00250
25-00260
25-00263
25-01675
26-00024
26-00025
26-00026
26-00027
26-00238
26-01674
26-08300
26-08619
26-08620
26-26600
27-00975
27-00976
PAGE 278
26-13107
JEV
FOR 40/48/50 HP 1989-UP
FOR SOME V4 1973-83
DESCRIPTION
Bolt
Screw
Screw
Seal
O-Ring (Pack of 5)
O-Ring
O-Ring
O-Ring
O-Ring (Pack of 5)
Seal
Grommet
Grommet
Oil Seal
Prop Shaft Seal
Water Pump Gasket
2
4
3
2
1
2
1
1
2
2
1
1
2
2
6
1
2
1
1
1
1
replaces:
JEV 0433550
SIE 18-2692
D09
10-02583
10-05220
10-08613
25-00063
25-00166
25-00227
25-00276
25-02442
25-02443
26-00062
26-01634
26-01756
26-01928
26-06013
26-26153
27-01936
QTY
Bolt
Screw
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Driveshaft Seal
Driveshaft Seal
Seal
Propshaft Seal
Seal
Seal
Seal
Seal
Sealing Washer
Gasket
GEARCASE SEAL KIT
replaces:
SIE 18-2694
COMPONENT
DESCRIPTION
D09
QTY
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
COMPONENT
25-00159
25-00166
25-00260
25-00262
25-00267
26-00024
26-00027
27-00922
27-00957
27-00975
DESCRIPTION
O-Ring (Pack of 5)
O-Ring (Pack of 5)
O-Ring
O-Ring (Pack of 5)
O-Ring (Pack of 5)
Driveshaft Seal
Seal
Solenoid Cover Gasket
of 5)
QTY
4
1
1
1
1
2
2
1
2
1
JOHNSON/EVINRUDE
26-00018
replaces:
CRANKSHAFT SEAL
JEV 0765461
JEV 0981268
FOR DRIVESHAFT HOUSING
FOR DRIVESHAFT HOUSING
SIE 18-2072
SIE 18-2073
D09
SEAL
26-00020
replaces:
D09
PROPSHAFT SEAL
JEV 0321467
D09
D09
26-00024
replaces:
SIE 18-2060
DRIVESHAFT SEAL
26-00025
replaces:
JEV 0321453
JEV 0329922
D09
D09
SIE 18-2026
DRIVESHAFT SEAL
26-00021
replaces:
JEV 0313353
SIE 18-2058
DRIVESHAFT SEAL
26-00019
replaces:
26-00026
replaces:
SIE 18-2061
SEAL
26-00027
replaces:
JEV 0329923
JEV 0330137
D09
D09
SIE 18-2062
SIE 18-2001
PAGE 279
(D) GEARCASE
SEAL
JOHNSON/EVINRUDE
(D) GEARCASE
DRIVESHAFT SEAL
26-00028
replaces:
JEV 0321928
DRIVESHAFT /
PROPSHAFT SEAL
SIE 18-2033
26-00064
replaces:
D09
PROPSHAFT SEAL
JEV 0321787
D09
D09
26-00066
replaces:
SIE 18-2031
DRIVESHAFT SEAL
JEV 0321480
D09
D09
26-00068
replaces:
SIE 18-2028
SEAL
26-00070
replaces:
JEV 0321481
JEV 0310649
D09
D09
SIE 18-2029
PAGE 280
26-00067
replaces:
JEV 0330327
SIE 18-2063
DRIVESHAFT SEAL
26-00065
replaces:
JEV 0321459
SIE 18-2027
DRIVESHAFT SEAL
JEV 0321466
SIE 18-2059
D09
DRIVESHAFT /
PROPSHAFT SEAL
26-00062
replaces:
SIE 18-2020
JOHNSON/EVINRUDE
26-00238
replaces:
JEV 0320862
DRIVESHAFT /
PROPSHAFT SEAL
SIE 18-2002
26-01047
replaces:
JEV 0314167
DRIVESHAFT /
PROPSHAFT SEAL
26-01049
JEV 0321786
D09
SEAL
26-01452
replaces:
JEV 0321788
JEV 0339620
D09
D09
SIE 18-2032
SEAL
26-01048
replaces:
SIE 18-2030
D09
replaces:
JEV 0313282
D09
SIE 18-2024
SEAL
replaces:
SIE 18-2023
D09
DRIVESHAFT /
PROPSHAFT SEAL
26-01045
(D) GEARCASE
PROPSHAFT SEAL
26-01579
replaces:
SIE 18-2074
CRANKSHAFT SEAL
26-01581
replaces:
JEV 0310599
JEV 0321895
D09
D09
SIE 18-2012
SIE 18-0543
PAGE 281
JOHNSON/EVINRUDE
(D) GEARCASE
SEAL
26-01583
replaces:
SEAL
JEV 0309989
JEV 0327031
D09
D09
SIE 18-2000
SEAL
26-01634
replaces:
SIE 18-2035
SEAL
JEV 0332205
SIE 18-2071
FOR GIMBAL HOUSING
D09
26-01957
replaces:
D09
SEAL
PAGE 282
26-01986
replaces:
JEV 3853655
JEV 0353076
D09
D09
SIE 18-2068
SEAL
26-01682
replaces:
JEV 0981195
SIE 18-2064
SEAL
26-01630
replaces:
26-02628
replaces:
SIE 18-2075
TEFLON LIP SEAL
26-02629
replaces:
JEV 0337085
JEV 0331103
D09
D09
SIE 18-8307
JOHNSON/EVINRUDE
26-06013
replaces:
SEAL
SEAL
JEV 0341280
D09
D09
26-08517
replaces:
SIE 18-8300
SEAL HOUSING
26-08519
replaces:
JEV 0339014
JEV 0340559
D09
D09
26-08619
replaces:
SEAL
26-08620
replaces:
JEV 0334950
JEV 0341281
D09
D09
SIE 18-8367
SEAL
replaces:
JEV 0342786
SIE 18-8325
SEAL
26-08300
(D) GEARCASE
OIL SEAL
26-08621
replaces:
SIE 18-8301
THERMOSTAT SEAL
26-08625
replaces:
JEV 0353076
JEV 0334742
D09
D09
SIE 18-1286
SIE 18-1734
PAGE 283
JOHNSON/EVINRUDE
(D) GEARCASE
PROP SHAFT SEAL
26-26150
replaces:
PROP SHAFT SEAL
JEV 0342787
JEV 0342887
D09
D09
SIE 18-8326
SEALING WASHER
SEAL
26-26600
replaces:
SEAL
JEV 0342247
D09
D09
26-08641
replaces:
SEAL
26-01674
replaces:
JEV 0332261
JEV 0332583
D09
D09
26-01602
replaces:
JEV 0320936
SIE 18-0540
D09
PAGE 284
26-26602
replaces:
JEV 0437330
SIE 18-2065
EXHAUST SEAL
26-26153
replaces:
SIE 18-7475
RUBBER WASHER (PACK
OF 10)
26-02143
replaces:
JEV 0332585
SIE 18-0559
PACK OF 10
D09
JOHNSON/EVINRUDE
25-00072
replaces:
O-RING (PACK OF 5)
JEV 0309731
PACK OF 5
PACK OF 5
SIE 18-7156
25-00152
replaces:
D09
O-RING (PACK OF 5)
JEV 0307450
PACK OF 5
PACK OF 5
SIE 18-7102
D09
25-00157
replaces:
D09
O-RING (PACK OF 5)
25-00158
replaces:
JEV 0321921
JEV 0554545
PACK OF 5
PACK OF 5
SIE 18-7411
SIE 18-7146
D09
O-RING (PACK OF 5)
25-00153
replaces:
JEV 0909316
SIE 18-7403
O-RING (PACK OF 5)
replaces:
JEV 0909139
D09
O-RING (PACK OF 5)
25-00150
25-00159
replaces:
D09
O-RING (PACK OF 5)
25-00162
replaces:
JEV 0317178
JEV 0303347
PACK OF 5
PACK OF 5
SIE 18-7109
D09
(D) GEARCASE
QUAD RING (PACK OF
5)
SIE 18-7180
D09
PAGE 285
JOHNSON/EVINRUDE
(D) GEARCASE
O-RING (PACK OF 5)
25-00164
replaces:
O-RING (PACK OF 5)
JEV 0308627
JEV 0301877
PACK OF 5
PACK OF 5
SIE 18-7104
SIE 18-7100
D09
O-RING (PACK OF 5)
25-00166
replaces:
D09
O-RING (PACK OF 5)
JEV 3852565
PACK OF 5
PACK OF 5
SIE 18-7153
D09
25-00204-50
replaces:
D09
O-RING (PACK OF 5)
JEV 0302588
D09
D09
25-00208
replaces:
SIE 18-7115
O-RING (PACK OF 5)
25-00209
replaces:
JEV 0307239
JEV 0326649
PACK OF 5
PACK OF 5
SIE 18-7170
D09
PAGE 286
25-00204-70
replaces:
JEV 0302588
SIE 18-7115
O-RING (PACK OF 5)
25-00203
replaces:
JEV 0318372
SIE 18-7137
O-RING (PACK OF 5)
25-00165
replaces:
SIE 18-7174
D09
JOHNSON/EVINRUDE
25-00210
replaces:
O-RING (PACK OF 5)
JEV 0302537
PACK OF 5
PACK OF 5
SIE 18-7164
D09
25-00223
replaces:
D09
O-RING (PACK OF 5)
JEV 0303360
D09
D09
25-00263
replaces:
SIE 18-7117
O-RING (PACK OF 5)
25-00270
replaces:
JEV 0354731
JEV 0909747
PACK OF 5
PACK OF 5
SIE 18-7130
SIE 18-7404
D09
O-RING (PACK OF 5)
25-00248-70
replaces:
JEV 0304174
SIE 18-7165
O-RING (PACK OF 5)
replaces:
JEV 0202893
SIE 18-7168
O-RING (PACK OF 5)
25-00211
(D) GEARCASE
O-RING (PACK OF 5)
25-00273
replaces:
D09
O-RING (PACK OF 5)
25-00560
replaces:
JEV 0303067
JEV 0909140
PACK OF 5
PACK OF 5
SIE 18-7116
D09
SIE 18-7402
D09
PAGE 287
JOHNSON/EVINRUDE
(D) GEARCASE
O-RING (PACK OF 5)
25-00786
replaces:
O-RING (PACK OF 5)
JEV 0307853
JEV 0333572
PACK OF 5
PACK OF 5
SIE 18-7120
SIE 18-7145
D09
O-RING (PACK OF 5)
25-01959
replaces:
D09
O-RING (PACK OF 5)
JEV 0318717
SIE 18-7440-1
PACK OF 5
D09
D09
25-03747
replaces:
O-RING (PACK OF 5)
JEV 0302035
PACK OF 5
PACK OF 5
D09
D09
25-25801
replaces:
JEV 0301917
PACK OF 5
D09
PAGE 288
25-07710
replaces:
JEV 0308624
SIE 18-7103
O-RING (PACK OF 5)
25-02110
replaces:
JEV 0301967
SIE 18-7138
O-RING (PACK OF 5)
25-01675
replaces:
QUAD RING
25-00071
replaces:
JEV 0909048
SIE 18-7477
D09
JOHNSON/EVINRUDE
25-00149
replaces:
O-RING
JEV 0326849
D09
D09
25-00201-70
replaces:
SIE 18-7144
O-RING
JEV 0302337
D09
D09
25-00228
replaces:
SIE 18-7162
O-RING
25-00260
replaces:
JEV 0321921
JEV 0313446
D09
D09
SIE 18-7411
O-RING
25-00207
replaces:
JEV 0307082
SIE 18-7152
O-RING
replaces:
JEV 0313175
SIE 18-7107
O-RING
25-00155
(D) GEARCASE
O-RING
25-00261
replaces:
SIE 18-7127
O-RING
25-00271
replaces:
JEV 0313754
JEV 0910238
D09
D09
SIE 18-7128
SIE 18-7136
PAGE 289
JOHNSON/EVINRUDE
(D) GEARCASE
O-RING
25-00276
replaces:
O-RING
JEV 0553126
JEV 0320303
D09
D09
SIE 18-7172
O-RING
25-01199
replaces:
SIE 18-7140
O-RING
O-RING
PAGE 290
25-01453
replaces:
JEV 0320140
JEV 0326741
D09
D09
SIE 18-7178
O-RING
25-00287
replaces:
25-02442
replaces:
SIE 18-7418
O-RING
25-07715
replaces:
JEV 0338522
JEV 0337087
D09
D09
25-25807
replaces:
O-RING
26-02745
replaces:
JEV 0324677
JEV 0335523
D09
D09
SIE 18-7110
JOHNSON/EVINRUDE
SCREW
10-03673
replaces:
SCREW
JEV 0909386
D10
Gearcase Fasteners
D10
Gearcase Fasteners
10-05193
replaces:
SCREW
10-05220
replaces:
JEV 0316563
JEV 0324852
D10
Gearcase Fasteners
D10
Gearcase Fasteners
10-08613
replaces:
SCREW
10-10101
replaces:
JEV 0309243
JEV 0304027
D10
Gearcase Fasteners
D10
Gearcase Fasteners
SIE 18-1236
SCREW
replaces:
JEV 0305282
SIE 18-2377
SCREW
10-04010
(D) GEARCASE
SCREW
10-10102
replaces:
SCREW
10-10103
replaces:
JEV 0331998
JEV 0337061
D10
Gearcase Fasteners
D10
Gearcase Fasteners
PAGE 291
JOHNSON/EVINRUDE
(D) GEARCASE
ANODE SCREW
SCREW & WASHER KIT
10-10120
replaces:
ANODE SCREW
10-22368
replaces:
JEV 0341219
JEV 0313715
D10
Gearcase Fasteners
D10
Gearcase Fasteners
93-08739
replaces:
BOLT
JEV 0345998/0916070
10-02500
replaces:
JEV 0341220
KIT CONTAINS REPLACEMENTS FOR
OEM PN’S 916070 AND 345998
D10
Gearcase Fasteners
D10
Gearcase Fasteners
BOLT
10-03715
replaces:
BOLT WITH O-RING
JEV 0318573
10-05223
replaces:
JEV 0332590
COMPONENT OF 10-03733 REAR
MOTOR MOUNT SERVICE KIT
D10
Gearcase Fasteners
D10
Gearcase Fasteners
BOLT
10-08614
replaces:
JEV 0317624
SIE 18-1279
D10
Gearcase Fasteners
PAGE 292
BOLT
10-08616
replaces:
JEV 0350271
SIE 18-1281
FOR RETAINING TAB
D10
Gearcase Fasteners
JOHNSON/EVINRUDE
COVER NUT
10-22369
replaces:
BOLT
JEV 0331999
D10
Gearcase Fasteners
D10
Gearcase Fasteners
11-08601
replaces:
SIE 18-4826
LOCKNUT 7/16-20
11-00118
replaces:
JEV 0911751
JEV 3852648
D10
Gearcase Fasteners
D10
Gearcase Fasteners
11-03668
replaces:
SIE 18-3721
SHIM .003 X 1.22
JEV 0313623
SIE 18-2232
D11
Shims
D10
Gearcase Fasteners
43-02921
replaces:
43-02920
replaces:
JEV 0323889
COMPONENT OF 10-03733 REAR
MOTOR MOUNT SERVICE KIT
SHIM .003
replaces:
JEV 0912127
SIE 18-3768
LOCKNUT
10-22371
(D) GEARCASE
BOLT
SHIM .003 X 1.58
43-02922
replaces:
JEV 0323362
JEV 0320166
D11
Shims
D11
Shims
SIE 18-2229
SIE 18-2224
PAGE 293
JOHNSON/EVINRUDE
(D) GEARCASE
SHIM .004 X 1.22
43-02923
replaces:
SHIM .004
JEV 0323890
JEV 0323361
D11
Shims
D11
Shims
SIE 18-2233
SHIM .004 X 1.56
43-02925
replaces:
SIE 18-2230
SHIM .005 X 1.22
JEV 0317232
D11
Shims
D11
Shims
43-02927
replaces:
SIE 18-2234
SHIM .006 X 1.53
PAGE 294
43-02929
replaces:
JEV 0314745
JEV 0320169
D11
Shims
D11
Shims
SIE 18-2231
SHIM .003
43-02926
replaces:
JEV 0320167
SIE 18-2225
SHIM .005
43-02924
replaces:
43-03648
replaces:
SIE 18-2227
SHIM .004
43-03649
replaces:
JEV 0313163
JEV 0313164
D11
Shims
D11
Shims
JOHNSON/EVINRUDE
SHIM .005
SHIM .007
SHIM .009
43-03652
replaces:
SHIM .004
43-03655
replaces:
JEV 0313167
JEV 0313194
D11
Shims
D11
Shims
43-03656
replaces:
SHIM .006
43-03657
replaces:
JEV 0313195
JEV 0313196
D11
Shims
D11
Shims
43-03658
replaces:
SHIM .008
43-03659
replaces:
JEV 0313197
JEV 0313198
D11
Shims
D11
Shims
43-03660
replaces:
SHIM .010
43-03661
replaces:
JEV 0313199
JEV 0313200
D11
Shims
D11
Shims
(D) GEARCASE
SHIM .007
PAGE 295
JOHNSON/EVINRUDE
(D) GEARCASE
SHIM .002
SHIM .004
SHIM .010
SHIM KIT
PAGE 296
43-03662
replaces:
SHIM .003
43-03663
replaces:
JEV 0313202
JEV 0313203
D11
Shims
D11
Shims
43-03664
replaces:
SHIM .005
43-03665
replaces:
JEV 0313204
JEV 0313205
D11
Shims
D11
Shims
43-03666
replaces:
SHIM .006
43-03667
replaces:
JEV 0313206
JEV 0313277
D11
Shims
D11
Shims
43-08344
replaces:
SHIM KIT
43-08345
replaces:
JEV
JEV
KIT CONTAINS 1 EACH: 003 323889
(43-02920) 004 323890 (43-02923)
005 317232 (43-02926)
KIT CONTAINS 1 EACH: 003 323362
(43-02921) 004 323361 (43-02924)
005 314745 (43-02927)
D11
Shims
D11
Shims
JOHNSON/EVINRUDE
SHIM
43-08346
replaces:
SHIM
43-08797
replaces:
JEV
JEV 0313275
D11
Shims
D11
Shims
43-08798
replaces:
SHIM
43-08799
replaces:
JEV 0313274
JEV 0313273
D11
Shims
D11
Shims
(D) GEARCASE
SHIM KIT
PAGE 297
JOHNSON/EVINRUDE
(E) ELECTRICAL
RECTIFIER & REGULATOR
ASSEMBLY
300-01402
replaces:
RECTIFIER
JEV 0581778
JEV 0583408
4 WIRE 4-5 AMP
3 WIRE 6-10 AMP
SIE 18-5709
SIE 18-5708
E01
Regulators & Rectifiers
ASSEMBLY
300-03585
replaces:
JEV 0586075
E01
ASSEMBLY
SIE 18-5830
300-03587
replaces:
JEV 0585001
ASSEMBLY
JEV 0395204
SIE 18-5825
FOR ALL V4 & V6 CROSSFLOW
MOTORS WITH 35 AMP 110-235 HP
E01
PAGE 298
JEV 0584890
FOR 25-35 HP 1995 & UP
E01
300-07150
300-03588
replaces:
SIE 18-5826
FOR 25-70 HP 1992 & UP
replaces:
JEV 0586048
E01
SIE 18-5827
ASSEMBLY
300-03586
replaces:
SIE 18-5829
E01
ASSEMBLY
300-01403
replaces:
E01
ASSEMBLY
300-08010
replaces:
JEV 0439561
SIE 18-5828
FOR V6 60° 150-175 HP 1991-95
E01
JOHNSON/EVINRUDE
300-08020
replaces:
JEV 0586271
ASSEMBLY
SIE 18-5831
83-07050
replaces:
JEV 0585195
FOR 90-115 1998-95 & V6 1988-91
BOTH LOOP CHARGED & CROSS
FLOW
E01
RECTIFIER
300-09021
replaces:
E01
IGNITION SWITCH
JEV 0584597
87-01946
replaces:
JEV 0508180
SIE MP39760
6 TERMINAL, 3 POSITION, PUSH TO
CHOKE
E01
IGNITION SWITCH
87-09022
replaces:
E02
Ignition Switch
POWER TRIM RELAY
300-01561
replaces:
JEV 0386545
JEV 0586224
5 TERMINAL, 3 POSITION, PISTOLSHAPED KEY
FOR ALL 3/4/6/8 CYL ENGINES.
1982 AND UP
SIE 18-1801
E02
Ignition Switch
SIE 18-5705
E04
Relays
PAGE 299
(E) ELECTRICAL
ASSEMBLY
JOHNSON/EVINRUDE
(F) TILT & TRIM
TILT AND TRIM SYSTEM
O-RING
O-RING & SEAL KIT
O-RING KIT
58-58104
replaces:
O-RING & SEAL KIT
JEV 0174520
JEV 0434519
FOR SHOWA POWER TILT AND TRIM
SYSTEM
SYSTEM
F02
Trim Seals
F02
Trim Seals
58-58105
replaces:
O-RING KIT
JEV 0174003
SYSTEM
SYSTEM
F02
Trim Seals
F02
Trim Seals
58-58102
replaces:
O-RING (PACK OF 5)
SIE 18-7457
F02
Trim Seals
F02
Trim Seals
25-02441
replaces:
25-01280
replaces:
JEV 0320527
SYSTEM
O-RING (PACK OF 5)
25-07510
replaces:
JEV 0335132
JEV 0321163
PACK OF 5
PACK OF 5
F02
Trim Seals
PAGE 300
58-58103
replaces:
JEV 0435567
JEV 0393942
O-RING (PACK OF 5)
58-58100
replaces:
SIE 18-7510
F02
Trim Seals
JOHNSON/EVINRUDE
25-07440
replaces:
QUAD RING
JEV 0301967
JEV 0328227
SIE 18-7440-1
FOR SHOWA TRIM SYSTEMS
F02
Trim Seals
LOCK WASHER
13-13101
replaces:
25-25810
replaces:
F02
Trim Seals
COMMUTATOR HEAD
JEV 0307161
300-26116
replaces:
JEV 0380704
USED ON OMC™ 382138. EMP™#
300-01512
F02
Trim Seals
END CAP
END CAP
58-58200
replaces:
F03
Trim Cylinder Repair Kits
END CAP
58-58201
replaces:
JEV 0173594
JEV 0320788
F03
F03
58-58202
replaces:
END CAP
58-58203
replaces:
JEV 0390006
JEV 0435345
F03
F03
PAGE 301
(F) TILT & TRIM
O-RING
JOHNSON/EVINRUDE
(F) TILT & TRIM
TRIM BUSHING
BUSHING
23-08514
replaces:
LOOPER TRIM BUSHING
JEV 0322481
JEV 0331010
FOR 3 & 3 CYL CROSSFLOW
MOTORS, 1979-91
FOR LOOPER TRIM SYSTEMS 1988
AND UP
F03
F03
23-08516
replaces:
TRIM MOTOR & CABLE
JEV 0393988
FOR NEW STYLE V4 & V6 TRIM
SYSTEMS
2 WIRE DESIGN FOR 3, 4, 6 AND 8
CYL 1982 THROUGH CURRENT
SIE 18-6759
300-03110
replaces:
F03
MOTOR WITH O-RING
JEV 5005254
FITS MOST 3, 4,9 AND 8 CYL 1982
AND UP
FITS ALL FFI MOTORS (V4/V6)
SIE 18-6281
F05
Motors & Reservoirs
300-08013
replaces:
F05
Motors & Reservoirs
MOTOR WITH O-RING
300-08014
replaces:
JEV 5005374
JEV 5005376
FITS 60, 70, 80, 90, 115, 150, 175,
200 AND 225 1991 AND LATER
FITS 60, 70, 80, 90, 115, 150, 175,
200 AND 225 1991 AND LATER
SIE 18-6780
F05
Motors & Reservoirs
PAGE 302
300-08012
replaces:
JEV 0985237
SIE 18-6759
MOTOR WITH O-RING
300-03109
replaces:
JEV 0335479
F03
TILT & TRIM MOTOR
23-08515
replaces:
SIE 18-6780
F05
Motors & Reservoirs
JOHNSON/EVINRUDE
300-08513
replaces:
300-26103
replaces:
JEV 0394176
JEV 0435548
FOR 100 & 155 HP 1991
FITS OMC™ O/B V6 1993 &
COMMERCIAL AND V8 1993 & UP
SIE 18-6759
F05
Motors & Reservoirs
TILT & TRIM MOTOR
TILT & TRIM MOTOR
SIE 18-6277
F05
Motors & Reservoirs
300-26104
replaces:
JEV 0437801
SIE 18-6280
FITS OMC™ J SUFFIX O/B’S 40, 48
AND 50 HP 1992 & UP
F05
Motors & Reservoirs
PAGE 303
(F) TILT & TRIM
TILT & TRIM MOTOR
JOHNSON/EVINRUDE
(G) IGNITION
TUNE-UP KIT
300-05001
replaces:
TUNE-UP KIT
JEV 0172525
JEV 0172523
INCLUDES 1PC 580256 (300-02883)
& 2PCS 580290 (300-02884)
INCLUDES 2 EA. 581419 (300-02886)
& 580148 (300-02882)
SIE 18-5001
SIE 18-5002
G01
Tune-up Kits
TUNE-UP KIT
300-05003
replaces:
G01
Tune-up Kits
TUNE-UP KIT
JEV 0172806
SIE 18-5006
INCLUDES 2 EA. 581419 (300-02886)
& 581207 (300-05141)
G01
Tune-up Kits
G01
Tune-up Kits
300-05011
replaces:
POINTS
JEV 0172521
SIE 18-5156
INCLUDES 1 EA. 580321 (30002885) & 580148 (300-02882)
G01
Tune-up Kits
G01
Tune-up Kits
300-02884
replaces:
JEV 0580290
SIE 18-5157
G01
Tune-up Kits
PAGE 304
300-02882
replaces:
JEV 0580148
SIE 18-5011
POINTS
300-05006
replaces:
JEV 0172522
SIE 18-5003
TUNE-UP KIT
300-05002
replaces:
TUNE-UP KIT
300-05011
replaces:
JEV 0172521
SIE 18-5011
INCLUDES 1 EA. 580321 (30002885) & 580148 (300-02882)
G01
Tune-up Kits
JOHNSON/EVINRUDE
PAGE 305
JOHNSON/EVINRUDE
(G) IGNITION
POINTS
300-05141
replaces:
CONDENSER
JEV 0581207
JEV 0580321
G01
Tune-up Kits
G01
Tune-up Kits
SIE 18-5141
CONDENSER
300-02886
replaces:
SIE 18-5199
CONDENSER
300-02883
replaces:
JEV 0581419
JEV 0580256
G01
Tune-up Kits
G01
Tune-up Kits
SIE 18-5205
TIMER BASE
300-02885
replaces:
300-09020
replaces:
SIE 18-5200
COIL
JEV 0584586
300-00724
replaces:
JEV 0763809
SIE 18-5163
FOR 18/20 HP 1973; 25 HP 1973-76
G01
Tune-up Kits
COIL
300-00725
replaces:
COIL
300-00726
replaces:
JEV 0502880
JEV 0502881
FOR 9.9-15 HP 1974-76 & 40 HP
1974
FOR 20 HP 1973, 25 HP 1973-76, 35
HP 1976 40 HP 1975-83
SIE 18-5196
G02
Ignition Coils & Sensors
PAGE 306
G02
SIE 18-5172
G02
JOHNSON/EVINRUDE
300-00727
replaces:
COIL
JEV 0502888
JEV 0502890
FOR 85/115 HP 1976-77;
135 HP 1976; 140 HP 1977;
150/175/200/235 HP 1976-78
FOR 50/65 HP 1971-75; 70/75 HP
1974-75; 85 HP 1973-75; 115 HP
1973-74; 135 HP 1973-75
SIE 18-5192
SIE 18-5194
G02
COIL KIT
300-00730
replaces:
G02
COIL
JEV 0584477
FOR 4 HP 1977-80; 4.5/6/7.5/8 HP
1980-84;6 HP 1977-79; 9.9/15 HP
1977-84; 25/30/35/40 HP 197784; OMC™ SAILDRIVE 1978-UP;
50/55/60 HP 1978-84; 65/70/75 HP
1979-84; V4-V6 1979-84; OMC™
SEA DRIVE (PLUG IN COIL) 1984-85
FOR 1.5/2 HP JUNIOR, COLT
1968-90; 3/4 HP 1950-76; 4 HP
1981-89; 5/5.5/6 HP 1950- 76; 7.5
HP 1954-58; 9.5 HP 1964- 73; 10 HP
1949-63; 15/18/20/25 HP 1951-72;
28/30/33/35 HP 1956-1970; 40 HP
1960-73
SIE 18-5181
G02
300-01991
replaces:
G02
IGNITION COIL
300-05837
replaces:
JEV 0582508
JEV 0583740
FOR 4 DELUXE 1985-UP; 6/8 HP
1985-90; 9.9/15/20/25/30 HP 1985UP; 30 HP 1985- UP; 40-50 HP 198588; 3 CYL. TO V8 (EXCEPT 150-175
LOOPER) 1985-UP
FOR 2.5 ULTRA/EXCEL 1987-88;
3/4/6/8 HP 1991-UP; 4 ULTRA/
EXCEL 1987-1990; 9.9/ 15 HP 1993UP; 40-50 HP 2 CYL.1989-UP; 90/115
LOOPER 1991- UP; 150-175 LOOPER
1991-UP
SIE 18-5179
SIE 18-5170
G02
WASHER (PACK OF 5)
300-00732
replaces:
JEV 0584561
SIE 18-5176
COIL
300-00729
replaces:
11-03700
replaces:
JEV 0329176
G02
LEAD
300-03708
replaces:
JEV 0583739
PACK OF 5
G02
G03
Plug Wires
PAGE 307
(G) IGNITION
COIL
JOHNSON/EVINRUDE
(G) IGNITION
SPARK PLUG LEAD WIRE
9”
84-03022
replaces:
PLUG WIRE (PACK OF 4)
JEV 0582365
JEV 0582365
G03
Plug Wires
G03
Plug Wires
SIE 18-5231-1
PLUG WIRE (PACK OF 6)
84-84005-6
replaces:
SIE 18-5231-1
AMPLIFIER ASSEMBLY
JEV 0389549
G03
Plug Wires
G04
Power Packs
300-00592
replaces:
SIE 18-5747
POWER PACK
JEV 0581726
G04
Power Packs
G04
Power Packs
300-01401
replaces:
SIE 18-5754
POWER PACK
300-03591
replaces:
JEV 0581731
JEV 0582125
G04
Power Packs
G04
Power Packs
SIE 18-5753
PAGE 308
300-01400
replaces:
JEV 0582556
SIE 18-5760
POWER PACK
300-01637
replaces:
JEV 0582365
SIE 18-5231-1
POWER PACK
84-84005-4
replaces:
SIE 18-5759
JOHNSON/EVINRUDE
300-03593
replaces:
POWER PACK
JEV 0582452
JEV 0763792
G04
Power Packs
G04
Power Packs
SIE 18-5758
POWER PACK
300-03595
replaces:
SIE 18-5769
POWER PACK
JEV 0763794
G04
Power Packs
G04
Power Packs
300-03597
replaces:
SIE 18-5783
POWER PACK
300-03709
replaces:
JEV 0583110
JEV 0585261
G04
Power Packs
G04
Power Packs
SIE 18-5784
POWER PACK
300-03596
replaces:
JEV 0763793
SIE 18-5782
POWER PACK
300-03594
replaces:
300-05761
replaces:
SIE 18-5785
POWER PACK
300-05762
replaces:
JEV 0583114
JEV 0582115
G04
Power Packs
G04
Power Packs
SIE 18-5761
SIE 18-5762
PAGE 309
(G) IGNITION
POWER PACK
JOHNSON/EVINRUDE
(G) IGNITION
POWER PACK
300-05763
replaces:
POWER PACK
JEV 0586800
JEV 0396141
G04
Power Packs
G04
Power Packs
SIE 18-5763
POWER PACK
300-05766
replaces:
SIE 18-5765
POWER PACK
JEV 0586798
G04
Power Packs
G04
Power Packs
300-05768
replaces:
SIE 18-5767
POWER PACK
JEV 0586661
G04
Power Packs
G04
Power Packs
300-06217
replaces:
SIE 18-5781
POWER PACK
300-07010
replaces:
JEV 0586667
JEV 0581397
G04
Power Packs
G04
Power Packs
SIE 18-5893
PAGE 310
300-05781
replaces:
JEV 5001344
SIE 18-5768
POWER PACK
300-05767
replaces:
JEV 0583748
SIE 18-5766
POWER PACK
300-05765
replaces:
SIE 18-5755
JOHNSON/EVINRUDE
300-07020
replaces:
POWER PACK
JEV 0582056
JEV 0582057
G04
Power Packs
G04
Power Packs
SIE 18-5756
POWER PACK
POWER PACK
300-07070
replaces:
SIE 18-5757
POWER PACK
300-07130
replaces:
JEV 0396077
JEV 0584028
G04
Power Packs
G04
Power Packs
300-07140
replaces:
SIE 18-5770
POWER PACK
300-08679
replaces:
JEV 0583489
JEV 0584985
G04
Power Packs
G04
Power Packs
SIE 18-5772
POWER PACK
300-07030
replaces:
300-26081
replaces:
SIE 18-5887
POWER PACK
300-26083
replaces:
JEV 0582262
JEV 0583865
G04
Power Packs
G04
Power Packs
SIE 18-5892
SIE 18-5885
PAGE 311
(G) IGNITION
POWER PACK
JOHNSON/EVINRUDE
(G) IGNITION
POWER PACK
300-26084
replaces:
POWER PACK
JEV 0584488
JEV 0584489
G04
Power Packs
G04
Power Packs
SIE 18-5883
POWER PACK
300-30010
replaces:
SIE 18-5794
SOLENOID
JEV 0584041
SIE 18-5808
FOR OMC™ I/O AND O/B
G04
Power Packs
89-00895
replaces:
G05
Solenoids
SOLENOID
JEV 0581528
FOR PRESTOLITE™ IGNITION,
OUTBOARD AND I/O
FOR 3 CYL., V4, V6 1974-81. FOR
OUTBOARD ONLY
SIE 18-5814
G05
Solenoids
89-13408
replaces:
G05
Solenoids
SOLENOID
89-26041
replaces:
JEV 0584128
JEV 0584580
FOR OUTBOARD ONLY
FOR 9.9-15 HP 1993-UP
SIE 18-5813
G05
Solenoids
PAGE 312
89-00898
replaces:
JEV 0378444
SIE 18-5807
SOLENOID
89-00890
replaces:
JEV 0586180
SIE 18-5772
SOLENOID
300-26085
replaces:
SIE 18-5823
G05
Solenoids
JOHNSON/EVINRUDE
300-01633
replaces:
JEV 0330525
STARTER PAWL (PACK
OF 2)
SIE 18-6512
PACK OF 2
G06
Starter Components
83-08669
replaces:
JEV 0318940
G06
Starter Components
STARTER BRUSH/
SPRING KIT
SIE 18-1505
93-06503
G06
Starter Components
REWIND SPRING
93-06511
replaces:
JEV 0318944
JEV 0312932
FITS 9.9, 15 1974-78
FITS 2, 4 HP 1969-1980 & 4, 4.5 HP
1980-90
SIE 18-6503
SIE 18-6511
G06
Starter Components
REWIND SPRING
JEV 0385952
FOR VARIOUS O/B STARTERS
G06
Starter Components
replaces:
300-05697
replaces:
SIE 18-5697
FOR 9.9 HP-15 HP 1974-1992
REWIND SPRING
JEV 0203698
SIE 18-6513
PACK OF 2
STARTER GEAR
300-01744
replaces:
93-06522
replaces:
JEV 0338534
SIE 18-6522
G06
Starter Components
REWIND SPRING
93-08787
replaces:
JEV 0336681
FITS 9.9, 15 1979-92
G06
Starter Components
G06
Starter Components
PAGE 313
(G) IGNITION
STARTER PAWL (PACK
OF 2)
JOHNSON/EVINRUDE
(G) IGNITION
SPRING
93-08668
replaces:
SPRING
JEV 0395460
93-08664
replaces:
JEV 0203725
SIE 18-6501
3, 5 1/2 & 7 1/2 HP 1954-1968; 10
HP 1950-1963; 12, 15, 18 & 20 HP
1956-1968; 20, 25, 28, 30 & 35 HP
1969-UP
G06
Starter Components
G06
Starter Components
SPRING
SPRING
STARTER
93-08665
replaces:
93-08666
replaces:
JEV 0330527
JEV 0331970
G06
Starter Components
G06
Starter Components
93-08667
replaces:
SPRING
93-08663
replaces:
JEV 0335905
JEV 0203697
G06
Starter Components
G06
Starter Components
50-02839
replaces:
STARTER
50-26011
replaces:
JEV 0586281
JEV 0778995
FITS 55-75 HP 3 CYL
FOR 9.9 & 15 HP
SIE 18-5635
G06
Starter Components
PAGE 314
SPRING
SIE 18-5617
G06
Starter Components
JOHNSON/EVINRUDE
50-26012
(G) IGNITION
STARTER
replaces:
JEV 0586287
SIE 18-5612
FITS V4 AND V6 ENGINES
G06
Starter Components
PAGE 315
JOHNSON/EVINRUDE
(H) FUEL
CARBURETOR REPAIR
KIT
1300-01427
replaces:
JEV 0398453
CARBURETOR KIT WITH
FLOAT
SIE 18-7223
FOR 20 HP 1969-70, 18, 20, 25 HP
1969-UP, 28, 30, 35 HP 1976-UP,
40 COMMERCIAL.1979-UP, 40,
45, 48, 50, 55 HP 1971-UP, 55 HP
1968- 69, 60 HP 1970-71, 60 2 CYL
1980-85, 50 TO 70 3 CYL 1972-UP,
75 HP 1975-88. MADE WITH FUEL
RESISTANT VITON RUBBER.
H01
Carburetor Kits
H01
Carburetor Kits
1300-01892
replaces:
JEV 0398532
CARBURETOR REPAIR
KIT
SIE 18-7043
1300-01894
JEV 0439075
H01
Carburetor Kits
CARBURETOR REPAIR
KIT
SIE 18-7024
1300-02362
JEV 0439079
SIE 18-7220
MADE WITH FUEL RESISTANT VITON
RUBBER.
H01
Carburetor Kits
PAGE 316
JEV 0439076
RUBBER.
H01
Carburetor Kits
replaces:
1300-01895
replaces:
SIE 18-7046
FOR 40 HP 1964-1970, 40 HP
1972-1978. OUR KIT INCLUDES THE
FLOAT!
CARBURETOR REPAIR
KIT
JEV 0439074
FOR 28 HP 1962-1964; 33 HP 19651970; 35 HP 1959; 40 HP MANUAL &
ELECTRIC 1960- 1963; 40 HP
H01
Carburetor Kits
replaces:
1300-01893
replaces:
SIE 18-7010
FOR 1.5, 2, JUNIOR, COLT 19701990, 4 HP 1968-78. OUR KIT
INCLUDES THE FLOAT! MADE WITH
FUEL RESISTANT VITON RUBBER.
CARBURETOR REPAIR
KIT
JEV 0396701
SIE 18-7222
FOR 9.9 1974-1988 AND 15 HP
1974-1988 OUR KIT INCLUDES THE
FLOAT! MADE WITH FUEL RESISTANT
VITON RUBBER.
CARBURETOR REPAIR
KIT
1300-01432
replaces:
H01
Carburetor Kits
CARBURETOR REPAIR
KIT
1300-02364
replaces:
JEV 0439078
SIE 18-7248
RUBBER.
H01
Carburetor Kits
JOHNSON/EVINRUDE
1300-08645
replaces:
JEV 0439070
CARBURETOR REPAIR
KIT
FOR 4BRH, R DELUXE 1984-UP, 4 HP
1979-80 4.5 W/ AUX. TANK 1980-3,
6-7.5-8 HP 1980-85. MADE WITH
H01
Carburetor Kits
1300-08647
replaces:
JEV 0439071
H01
Carburetor Kits
CARBURETOR REPAIR
KIT
SIE 18-7043
1300-08689
JEV 0438996
JEV 0437327
FOR V4 & V6 90 DEG. LOOPER
1988-01. MADE WITH FUEL
H01
Carburetor Kits
replaces:
1300-08688
replaces:
SIE 18-7248
FOR 3 HP 1952-1967, 4 HP 1965-67,
5 HP 1965-67, 5.5-6 HP 1954-67,
6 HP 1969- 79, 7.5 HP 1956-58, 10
HP 1954-63, 15 HP 1956, 18-20
HP 1957-68. MADE WITH FUEL
CARBURETOR REPAIR
KIT
JEV 0439072
SIE 18-7223
FOR ULTRA, EXCEL 4+2.5 19871990, 3 HP 1989-UP, 4BR 1981-83,
4.5 W/ INTERNAL TANK 1980-1983.
RUBBER.
CARBURETOR REPAIR
KIT
1300-08646
replaces:
H01
Carburetor Kits
CARBURETOR REPAIR
KIT
SIE 18-7247
1300-08690
replaces:
JEV 0382048
FOR 90-115 HP 60 DEG. LOOPER
1995-UP, 150-175 LOOPER 1991-UP.
RUBBER.
H01
Carburetor Kits
H01
Carburetor Kits
CARBURETOR REPAIR
KIT
1300-36019
replaces:
JEV 0439078/0439079
SIE 18-7248
CARBURETOR REPAIR
KIT
1300-08691
replaces:
JEV 0439073
SIE 18-7219
RUBBER.
FOR 6-8 HP 1986-UP; 9.9 HP 1989UP; 15 HP1989-UP, 20 HP.991-UP.
RUBBER.
H01
Carburetor Kits
H01
Carburetor Kits
PAGE 317
(H) FUEL
CARBURETOR REPAIR
KIT
JOHNSON/EVINRUDE
(H) FUEL
NITROPHYL FLOAT
1300-36063
replaces:
NEEDLE & SEAT
JEV 0382363
JEV 0396520
H01
Carburetor Kits
H01
Carburetor Kits
SIE 18-7210
SCREW THROTTLE CAM
1399-01410
replaces:
10-10904
replaces:
JEV 0316037
SIE 18-7038
LOCK WASHER (PACK
OF 5)
13-21761
replaces:
JEV 0328701
PACK OF 5
H01
Carburetor Kits
RETAINER
1399-13486
replaces:
H01
Carburetor Kits
O-RING (PACK OF 5)
JEV 0315232
JEV 0305739
PACK OF 5
PACK OF 5
SIE 18-7296
SIE 18-7101
H01
Carburetor Kits
VALVE FOR PRIMER
1399-39021
replaces:
JEV 0175158
SIE 18-0871
H02
Fuel Connectors
PAGE 318
25-00154
replaces:
H01
Carburetor Kits
HOSE BARB 1/4” X
5/16”
22-00844
replaces:
JEV 0173311
SIE 18-8055
MALE BRASS 1/4” NPT X 5/16”
HOSE BARB
H02
Fuel Connectors
JOHNSON/EVINRUDE
54-01368
replaces:
CLAMP SIZE #4
JEV 0124249
RANGE: 344-.406 HOSE SIZE: 2
SIE 18-8201
H02
Fuel Connectors
54-01370
replaces:
H02
Fuel Connectors
CLAMP SIZE #8
JEV 0322654
SIE 18-8020
H02
Fuel Connectors
H02
Fuel Connectors
54-01372
replaces:
CLAMP SIZE #12
54-01373
replaces:
Universal
Universal
H02
Fuel Connectors
H02
Fuel Connectors
SIE 18-8021
CLAMP SIZE #14
54-01371
replaces:
Universal
SIE 18-8202
CLAMP SIZE #10
replaces:
JEV 0322653
SIE 18-8200
CLAMP SIZE #6
54-01369
(H) FUEL
CLAMP SIZE #2
54-01374
replaces:
JEV 0329653
SIE 18-8203
SIE 18-8034
HOSE CLAMP (PACK OF
2)
54-54902
replaces:
Misc Other/Universal
UNIVERSAL
SIE 18-6834
PACK OF 2
H02
Fuel Connectors
H02
Fuel Connectors
PAGE 319
JOHNSON/EVINRUDE
(H) FUEL
VRO REPLACEMENT FUEL PUMP
1399-07359
FUEL PUMP
1399-07350
replaces:
JEV 0397839
H03
Fuel Pumps
FOR 6, 8, 9.9, 15 HP THRU 1992
replaces:
RELATED PRODUCT:
JEV
Fuel Pump Repair Kit
1399-01604
EMP EXCLUSIVE!
NON-OILING FUEL PUMP FOR 90-250 HP V4/V6 CROSSFLOW AND LOOPER
(WILL NOT FIT 60º APPLICATION)
replaces:
JEV 0393088
SIE 18-7823
H03
Fuel Pumps
KIT FOR 397839
FUEL PUMP
1399-07352
H03
Fuel Pumps
replaces:
JEV 0438556
SIE 18-7352
NON VRO BLOCK MOUNT PULSE.
FOR 25-55 HP & V4 1976-78
RELATED PRODUCT:
1399-01642
FUEL PUMP
1399-07351
H03
Fuel Pumps
replaces:
JEV 0438562
SIE 18-7351
BLOCK MOUNT PULSE. FOR 9.9,
15 HP
RELATED PRODUCT:
1399-01434
replaces:
JEV 0432962
replaces:
JEV 0393103
KIT FOR 438556
KIT FOR 438562
SIE 18-7822
PAGE 320
SIE 18-7350
SIE 18-7820
JOHNSON/EVINRUDE
PAGE 321
JOHNSON/EVINRUDE
(H) FUEL
FUEL PUMP
FUEL PUMP
1399-07353
H03
Fuel Pumps
replaces:
JEV 0438555
SIE 18-7353
EXTERNAL PULSE LINE-20, 30, 40,
50 HP 1990-2000
RELATED PRODUCT:
1399-07357
H03
Fuel Pumps
RELATED PRODUCT:
1399-01641
1399-08603
replaces:
JEV 0398514
replaces:
JEV 0438616
KIT FOR 438555
FOR 9.9, 15 ELE 1990-UP, 20, 30 HP
1990-UP, 40, 45, 48, 50, 88, 100, 125 HP
1990-UP
SIE 18-7821
LEAF VALVE
CHECK VALVE
replaces:
JEV 0438559
93-02783
replaces:
SIE 18-7800
LEAF VALVE
93-02784
replaces:
JEV 0313420
JEV 0317739
FOR 3 CYL 1985-1995
FOR V4 CROSS 1985-96 & V6
CROSS 1985-95
H04
Fuel Pump Kits
H04
Fuel Pump Kits
1300-36385
replaces:
JEV 0436385
CHECK VALVE
1300-92988
replaces:
JEV 0392988
FOR FRONT OF 200-225 FICHT &
CARB ENGINES (90° 1993-UP)
H04
Fuel Pump Kits
PAGE 322
H04
Fuel Pump Kits
JOHNSON/EVINRUDE
1300-36194
replaces:
VALVE
JEV 0436194
SIE 18-7796
H04
Fuel Pump Kits
H04
Fuel Pump Kits
1399-13990
replaces:
JEV 0437228
FUEL PUMP GASKET
(PACK OF 5)
SIE 18-0993
27-00772
replaces:
H05
Fuel Seals & Gaskets
FUEL PUMP GASKET
JEV 0321793
27-00989
JEV 0338879
SIE 18-2900
FOR FILTER CAP TO PUMP. MADE
WITH FUEL RESISTANT VITON
RUBBER.
H05
27-00916
replaces:
JEV 0338876
SIE 18-2879
FOR FILTER CAP TO PUMP. MADE
WITH FUEL RESISTANT VITON
RUBBER.
H05
replaces:
JEV 0303615
FUEL PUMP TO BLOCK
PACK OF 5
SIE 18-0975
FUEL PUMP GASKET
27-00759
replaces:
SIE 18-0850
H05
CARBURETOR SILENCER
GASKET
replaces:
JEV 0335334
FOR FRONT OF 200-225 FICHT &
CARB ENGINES (90° 1993-UP)
COVER & GASKET
ASSEMBLY
93-13508
(H) FUEL
CHECK VALVE
H05
CARBURETOR GASKET
(PACK OF 5)
27-00953
replaces:
JEV 0314477
SIE 18-0118
H05
PAGE 323
JOHNSON/EVINRUDE
(H) FUEL
FLOAT BOWL GASKET
27-00993
replaces:
FLOAT BOWL GASKET
JEV 0338880
JEV 0338884
RUBBER.
V4 & V6 CROSSFLOW. MADE WITH
SIE 18-2903
SIE 18-2906
H05
THROTTLE BODY
GASKET
27-01977
replaces:
H05
FLOAT BOWL GASKET
JEV 0326838
SIE 18-2582
V4 & V6 LOOPER. MADE WITH FUEL
H05
GASKET
PAGE 324
27-02585
replaces:
27-02361
replaces:
JEV 0338813
SIE 18-0987
FLOAT BOWL GASKET
(PACK OF 5)
27-00995
replaces:
H05
GASKET
27-27120
replaces:
JEV 0343512
JEV 0341284
PACK OF 5. MADE WITH FUEL
V4/V6 LOOPER. MADE WITH FUEL
H05
H05
27-27121
replaces:
GASKET
27-27122
replaces:
JEV 0341287
JEV 0341258
H05
H05
JOHNSON/EVINRUDE
27-27241
replaces:
CARBURETOR GASKET
JEV
SIE 18-2800
CONTAINS ONE EACH: 27-00993
AND 27-02585. MADE WITH FUEL
H05
H05
25-00267
replaces:
JEV 0322598
O-RING (PACK OF 5)
SIE 18-7105
PACK OF 5
PACK OF 5
H05
25-02360
replaces:
H05
O-RING
25-02355
replaces:
JEV 0328650
JEV 0332253
RUBBER.
V4 & V6 LOOPER. MADE WITH FUEL
SIE 18-8352
H05
5/16” INLINE FUEL
FILTER
25-01437
replaces:
JEV 0311338
SIE 18-7120
O-RING
replaces:
JEV 0508798
SIE 18-1241
O-RING (PACK OF 5)
27-00629
(H) FUEL
FLOAT & NOZZLE
GASKET SET
35-01227
replaces:
H05
FUEL FILTER ASSEMBLY
35-35209
replaces:
JEV 0398327
JEV 5007335
5/16” FILTER
E-TEC JEV 40, 50, 60, 75, 90, 115, 150,
175 & 200DPL
SIE 18-7830
H06
Fuel Filters
SIE 18-7722
H06
Fuel Filters
PAGE 325
JOHNSON/EVINRUDE
SPECIAL
SECTION: FUEL FILTERS & ACCESSORIES
(H) FUEL
5/16” INLINE FUEL
FILTER
35-01227
replaces:
1/4” INLINE FUEL FILTER
JEV 0398327
Mercury 35-16494
5/16” FILTER
1/4” LARGE CAPACITY
SIE 18-7830
SIE 18-7829
H06
Fuel Filters
FUEL FILTER KIT
35-01449
replaces:
H06
Fuel Filters
FUEL FILTER
Merc 35-53336Q
FOR 2 & 4 BARREL ROCHESTER
CARBURETORS
FOR 2 & 4 BARREL ROCHESTER
AND MERCARB CARBURETORS
SIE 18-7859
H06
Fuel Filters
35-35209
replaces:
H06
Fuel Filters
FUEL FILTER
JEV 5007335
SIE 18-7860
E-TEC JEV 40, 50, 60, 75, 90, 115,
150, 175 & 200DPL
H06
Fuel Filters
H06
Fuel Filters
35-35204
replaces:
FUEL FILTER
35-35205
replaces:
Mercury 35-877565T 1
Mercury 35-879885Q
H06
Fuel Filters
H06
Fuel Filters
SIE 18-7714
PAGE 326
35-00107
replaces:
OMC 0312456
SIE 18-7722
FUEL FILTER
35-00106
replaces:
Merc 1397-8767Q
SIE 18-7869
FUEL FILTER ASSEMBLY
35-00600
replaces:
SPECIAL SECTION: FUEL FILTERS
JOHNSON/EVINRUDE
& ACCESSORIES
35-01679
replaces:
FUEL FILTER
Yamaha
SIE 18-7861
CANISTER AND FILTER
H06
Fuel Filters
35-01461
replaces:
H06
Fuel Filters
FUEL FILTER & GASKET
OMC 0984491
SIE 18-7862
REPLACEMENT ELEMENT. INCLUDES
GASKET
H06
Fuel Filters
35-35201
replaces:
H06
Fuel Filters
FUEL FILTER
35-01460
replaces:
Mercury 881540
OMC 0983870
H06
Fuel Filters
H06
Fuel Filters
SIE 18-7979
FUEL FILTER
35-01647
replaces:
OMC 0982230
SIE 18-7854
FUEL FILTER
replaces:
OMC 0981911
SIE 18-7831
FUEL FILTER
35-01646
35-35202
replaces:
(H) FUEL
SIE 18-7855
FUEL FILTER (PACK OF 2)
35-01501
replaces:
Mercury 35-888289T 2
Merc 35-803897Q 1
FITS 225-250 HP 4 STROKE ENGINES
FUEL FILTER, SPRING AND GASKETS
FOR THE FILTER BOWL. FOR MCM
120 / 2.5L, 140 / 3.0L / LX, 3.7L,
3.8L, 4.3L
PACK OF 2
SIE 18-7936
H06
Fuel Filters
SIE 18-7784
H06
Fuel Filters
PAGE 327
JOHNSON/EVINRUDE
SPECIAL
SECTION: FUEL FILTERS & ACCESSORIES
(H) FUEL
FUEL PUMP STRAINER
35-35401
replaces:
Yamaha 60V-24251-01-00
FUEL WATER SEPARATOR KIT
SIE 18-79907
H06
Fuel Filters
35-13518
replaces:
37-07946-014 Universal
replaces:
Misc Other/Universal
SIE 18-7983-1
SIE 18-7828-1
UNIVERSAL FILTER HEAD KIT FOR OMC AND
OTHER ENGINES.
H06
Fuel Filters
1/4” SMALL CAPACITY
COMPONENT
35-06050
35-06040
22-06055
DESCRIPTION
1/4” Aluminum Filter Head
Fuel Filter
1/4” plug (2 pk)
QTY
1
1
1
H06
Fuel Filters
replaces:
37-07946-038 Universal
H06
Fuel Filters
COMPONENT
35-06053
35-06040
22-22038
PAGE 328
37-07946-038SS
UNIVERSAL FILTER HEAD KIT FOR OMC AND
OTHER ENGINES.
DESCRIPTION
3/8” Aluminum Filter Head
Fuel Filter
3/8” plug (2 pk)
QTY
1
1
1
replaces:
Universal
UNIVERSAL FILTER HEAD KIT FOR OMC
AND OTHER ENGINES.
H06
Fuel Filters
COMPONENT
35-35038
35-06040
22-22038
DESCRIPTION
3/8” SS Filter Head
Fuel Filter
3/8” plug (2 pk)
QTY
1
1
1
SPECIAL SECTION: FUEL FILTERS
JOHNSON/EVINRUDE
& ACCESSORIES
35-06040
replaces:
Universal
1/4” ALUMINUM FILTER
HEAD
SIE 18-7846
35-06053
replaces:
Universal
1/4” INLETS/OUTLETS. FOR USE WITH
1” FILTERS.
H06
Fuel Filters
3/8” SS FILTER HEAD
35-35038
replaces:
Universal
Universal
GET MAXIMUM FUEL FLOW WITH
3/8” INLETS/OUTLETS. FOR USE WITH
1” FILTERS.
NEW! STAINLESS STEEL VERSION OF
OUR 35-06053. GET MAXIMUM FUEL
FLOW WITH 3/8” INLETS/OUTLETS.
FOR USE WITH 1” FILTERS.
SIE 18-7775
SIE 18-7776
H06
Fuel Filters
PLUG 1/4” (PACK OF 2)
replaces:
SIE 18-7853-1
H06
Fuel Filters
3/8” ALUMINUM FILTER
HEAD
35-06050
(H) FUEL
FUEL FILTER
22-06055
replaces:
H06
Fuel Filters
PLUG 3/8” (PACK OF 2)
22-22038
replaces:
Universal
Universal
FOR THE EMP™ 35-06050 FILTER
HEAD. BRASS 1/4” NPT WITH
VIBRASEAL
FOR THE EMP™ 35-06053 FILTER
HEAD. BRASS 3/8” NPT WITH
VIBRASEAL
SIE 18-8111
H06
Fuel Filters
SIE 18-4264
H06
Fuel Filters
PAGE 329

Johnson / Evinrude

Transcription

Similar documents

2016 Industrial Catalogue - Pacific Industrial Access