Breakdown ID - Dr. Mennicken GmbH

Breakdown ID
D
K
W
- Double- Small- AngleB
F
KL
M
MA
O
R
S
- Bayonet- Surface- Clamp- Mineral insulated- Melt- Uninsulated (for air temperaure measurement)
- Clamp- Plug in-
T
WDF
- Thermocouple
- Resistance Temperature Sensors
K
L
N
V
O
- only bayonet cap, without nipple
- with mounting bracket
- temperature sensor has only a nipple, without bayonet cap
- complete with bayonet cap and nipple
- without exposed thermocouple wires(only at ClampThermocouple)
H
P
S
SP
- hemispherical
- plane
- pointed, 118° drill angle
- pointed - plane
XXX
- internal code of the thermocouple
m
k
n
g
gS
- bayonet cap “m”,
- bayonet cap “k”,
- bayonet cap “n”,
- bayonet cap “g”,
- bayonet cap “gS”,
with pins, pin spacing
ID 10,5 mm
ID 12,8 mm
ID 14,8 mm
ID 16,8 mm
ID 15,8 mm
13,2 mm
add “ po”, if it must be potential-free
after this breakdown follows the
thread from the nipples, the
length from the nippels or the diameter
of the sensor, the depth of immersion and
the length from the connecting cable
(specification in m)
D
B
T
-
V
S
2
n
po
/ M 12 x 1/ 50mm long/ 3,0
(example)
Subject to modifications!
05/02
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0001
Thermocouple
Type : BT-KP 1
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5/ 6 mm (VA)
installation depth
: ca. 15 to ca. 35 mm
bayonet cap
: Ms 58 nickel-plated
controll point
: soldered/ plane
compression spring : V2A
Ø12
65
kink protection
spring
: V2A
operating
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Druckfeder
(compression spring)
16
~40 bei gedrückter Feder
(solid length = 40)
18
~100
Ø7,8
Ø5
Other customer preferences are possible.
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0002
30
Mineral insulated-Thermocouple
Type : MT-1,5
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 1,5 mm/ 2,5 mm
sheath material
: V4A
1.4541
Inconel 2.4816
smallest bending
radius
: about five times the outer
diameter of the sheath
installation depth
: L to customer
jacket insulation
: MgO
controll point
: free of potential
test voltage
: 100 VDC
operation
temperature
: measuring point to 800°C
transition piece to 200°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø2,5
L
5
Ø5
Other customer preferences are possible
Subject to modifications!
Ø1,5
05/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0002 A
Mineral insulated-Thermocouple
Type : MT-1,0
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 1,0 mm/ 2,0 mm
sheath material
: V4A
1.4541
Inconel 2.4816
smallest bending
radius
: about five times the outer
diameter of the sheath
installation depth
: L to customer
jacket insulation
: MgO
controll point
: free of potential
test voltage
: 100 VDC
operation
temperature
measuring point to 600°C
: transition piece to 200°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø5
Ø2
Other customer preferences are possible
Subject to modifications!
25/03
Ø1
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0002 B
Ø3,5
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 1,0 mm
sheath material
: V4A
1.4541
Inconel 2.4816
smallest bending
radius
: about five times the outer
diameter of the sheath
installation depth
: L to customer
jacket insulation
: MgO
controll point
: free of potential
test voltage
: 100 VDC
operation
temperature
: measuring point to 600°C
transition piece to 200°C
thermocouple wire
: 2 x 0,22 mm²
fiber glass insulation
and specially impregnated
wire stainless steel wire mesh
L
25
Mineral insulated-Thermocouple
Type : KMT-1,0
Other customer preferences are possible
Subject to modifications!
Ø1
31/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0003
Angle-Thermocouple
Type : WBT-KP 1
min. 15
43
~R=10
Ø12 (o.n. Angabe)
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5/ 6 mm (VA)
installation depth
: A+B to customer
bayonet cap
: Ms 58 nickel-plated
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
50
(or your specification)
Druckfeder
(compression spring)
A
Ø6
Ø5
Maße für A nach Angabe
(dimension for A to be made
to your specification)
Other customer preferences are possible
Subject to modifications!
42/13
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
:.
Data Sheet 0005
Thermocouple
Type : BT-VP 2
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (VA)
installation depth
: ca. 15 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø8
compression spring : V2A
~195
Ø 14,8 (o. n. Angabe) *
controll point
: welded/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø14 (o.n. Angabe) *
SW 17 ( o. n. Angabe) *
Gewinde nach Angabe *
thread
* = (your specification)
Other customer preferences are possible
Subject to modifications!
10
25/03
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0006
Thermocouple
Type : BT-VS 2
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (VA)
installation depth
: ca. 15 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø8
compression spring : V2A
~195
Ø 14,8 (o. n. Angabe) *
Ø14 (o.n. Angabe)
*
controll point
: welded/ 118° drill angle
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
SW 17 (o. n. Angabe) *
Gewinde nach Angabe
thread
* = (your specification)
Other customer preferences are possible
Subject to modifications!
12
25/03
Ø8
118°
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0007
Mineral insulated-Thermocouple
Type : MT-2,0
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 2,0 mm/ 3,0 mm
sheath material
: V4A
1.4541
Inconel 2.4816
smallest bending
radius
: about five times the outer
diameter of the sheath
installation depth
: L to customer
jacket insulation
: MgO
controll point
: free of potential
test voltage
: 100 VDC
operation
temperatur
: measuring point to 800°C
transition piece to 200°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø5
Ø3
Other customer preferences are possible
Subject to modifications!
25/03
Ø2
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0009
Mineral insulated-Thermocouple
Type : MT-3,0
Ø5
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,0 mm
sheath material
: V4A
1.4541
Inconel 2.4816
smallest bending
radius
: about five times the outer
diameter of the sheath
installation depth
: L to customer
jacket insulation
: MgO
controll point
: free of potential
test voltage
: 100 VDC
operation
temperature
: measuring point to 800°C
transition piece to 200°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
Ø3
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
25/03
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0010
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 2 mm (VA)
installation depth
: ca. 17 mm incl. thread
sheath material
: 1.4301
nipple
: SW 7/ M4 aus Ms58
SW 7
controll point
: soldered/ hemispherical
M4
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,5 mm
jacket with glass fibre and
specially impregnated
11
17
Small-Thermocouple
Type : KT-NH 3
Ø2
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
:
Data Sheet 0011
Thermocouple
Type : BT-VH 3
Special features:
-
ceramic insulation of the measuring point
against heat dissipation outward
-
very good heat-absorbing of the hemisphericalen
measuring point by argentiferous brazing alloy
Ø8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6/ 8 mm
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
~195
Ø 14,8 (o.n. Angabe) *
Ø14 (o.n. Angabe) *
SW 17 o. n Angabe)
*
Gewinde nach Angabe *
compression spring : V2A
thread
controll point
: ceramic insulated/
hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
~4 ~5
* = (your specification)
Ø6
Other customer preferences are possible
Subject to modifications!
Ø8
39/13
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0012
Thermocouple
Type : BT-VP 3
Special features:
-
ceramic insulation der measuring point
against heat dissipation outward
Ø8
~195
Ø14,8 (o. n. Angabe) *
Ø14 (o.n. Angabe) *
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6/ 8 mm
installation depth
: ca. 15 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
compression spring : V2A
SW 17 (o. n. Angabe) *
Gewinde nach Angabe *
thread
~3 ~5
* = (your specification)
controll point
: ceramic insulated/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
Ø6
42/13
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0013
Angle-Thermocouple
Type : WT-NH 3
70
Ø6,8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm
installation depth
: ca. 7 to 9 mm incl. thread
nipple
: Ms 58 nickel-plated
controll point
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
~42
~R=10
SW 10
M 8x1
Ø6
Ø5
Other customer preferences are possible
Subject to modifications!
42/13
~1
4
6 3
~26
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0014
Thermocouple
Type : T-NH 3
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm
installation depth
: ca. 7 to 9 mm incl. thread
nipple
: Ms 58 nickel-plated
controll point
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
100
Ø7,8
25
Ø6
65
Ø5
Other customer preferences are possible
Subject to modifications!
4
M8x1
~1
3 6
25/03
SW 10
Ø6
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0015
Thermocouple
Type : BT-VP 4
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5/ 6 mm (VA)
installation depth
: ca. 35 to 100 mm
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø6,5
15
Ø14
Ø10,5
~100
Ø9,7
20
compression spring : V2A
SW 11
M 10x1
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
28
3
Ø6
Other customer preferences are possible
Subject to modifications!
25/03
Ø5
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0016
Angle-Thermocouple
Type : WST-H 4
Ø6
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5 mm (VA)
installation depth
: A+B to customer
controll point
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
25/03
~R=10
A
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0017
Thermocouple
Type : BT-VP 5
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,8/ 8 mm (Ms)
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
~195
Ø8
Ø 14,8 (o. n. Angabe) *
Ø14 (o.n. Angabe) *
SW 17 ( o. n. Angabe) *
Gewinde nach Angabe *
thread
* = (your specification)
Other customer preferences are possible
Subject to modifications!
Ø6
18
Ø8
20
25/03
Ø3,8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
:
Data Sheet 0019
Thermocouple
Type : BT-VP 7
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,8/ 8 mm (Ms)
installation depth
: ca. 16 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø8
~195
compression spring : V2A
Ø 14,8 (o.n. Angabe) *
Ø14 (o.n. Angabe)
*
SW 17 ( o.n. Angabe) *
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Gewinde nach Angabe
thread
* = (your specification)
Other customer preferences are possible
Subject to modifications!
Ø6
25/03
16
18
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Ø3,8
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0020
Thermocouple
Type : BT-VS 9
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6/ 8 mm (VA)
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø8
compression spring : V2A
~195
Ø14,8 (o.n. Angabe) *
Ø14 (o.n. Angabe) *
controll point
: soldered/ 118° drill angle
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
SW 17 (o. n. Angabe) *
Gewinde nach Angabe *
thread
* = (your specification)
Ø6
Other customer preferences are possible
Subject to modifications!
Ø8
20
25
25/03
Ø6
118°
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0021
Thermocouple
Type : BT-VSP 9
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6/ 8 mm (VA)
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø8
compression spring : V2A
~195
Ø14,8 (o.n. Angabe) *
Ø14 (o.n. Angabe) *
controll point
: soldered/ 118° drill angle/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
SW 17 (o.n. Angabe) *
Gewinde nach Angabe *
thread
* = (your specification)
Ø6
Other customer preferences are possible
Subject to modifications!
Ø8
20
25
25/03
Ø6
118°
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0024
Angle-Thermocouple
Type : WST-P 12
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (VA)
installation depth
: 40 mm (or to customer)
Ø6,5
~100
kink protection:
spring
V2A
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø8
20
Other customer preferences are possible
Subject to modifications!
7
Dr. Mennicken GmbH
Industrie-Elektronik
33/05
40
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0025
Angle-Thermocouple
Type : WBT-VP 12
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (VA)
installation depth
: L to customer
nipple
: Ms 58 nickel-plated
Ø6,5
compression spring : V2A
V2A
~100
kink protection:
spring
Gewinde nach Angabe *
thread
5
controll point
: welded / plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø8
20
O 12,8 (o.n. Angabe)
SW 17 (o.n. Angabe) *
*
*
= your specification
7
L
Other customer preferences are possible
Subject to modifications!
25/05
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0027
uninsulated Thermocouple
Type : OST-14
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm (VA)
installation depth
: L to customer
controll point
: uninsulated/ punctual
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
L
thermoelectric
voltages
Other customer preferences are possible
Subject to modifications!
25/03
Ø6
L = 40 - 300mm nach Angabe
(or your specification)
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0028
Thermocouple
Type : T-NP 15
Ø6
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8,8 mm/ M 10 x 1 (VA)
installation depth
: to ca. 24 mm incl. thread
nipple
: Ms 58 nickel-plated
controll point
: welded/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
SW 10
M 10x1
Other customer preferences are possible
Subject to modifications!
Ø8,8
30/06
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0029
Plug in-Thermocouple
Type : ST-P 16
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm (VA)
installation depth
: L to customer
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
L
thermoelectric
voltages
Other customer preferences are possible
Subject to modifications!
Ø6
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
25/03
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0030
Surface-Thermocouple
Type : FT-17
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: contact surface 20 x 8 mm (VA)
mounting hole
: Æ 4,5 mm
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
4
8
20
Ø 4,5
~100
Ø7,8
25/03
3,5
8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0031
Angle-Thermocouple
Type : WST-H 17
Ø7,8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 4 mm (VA)
installation depth
: 12 mm (or to customer)
controll point
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
12
Other customer preferences are possible
Subject to modifications!
25/03
3,5
8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0033
Thermocouple
Type : BT-KP 19
~195
Ø8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,8/ 5/ 8 mm (VA)
installation depth
: A+B to customer
bayonet cap
: Ms 58 nickel-plated
compression spring : V2A
Ø12,8
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
B
Ø8
controll point
Ø5
Other customer preferences are possible
Subject to modifications!
25/03
A
Ø3,8
Maße für A,B nach Angabe
(dimension f. A,B to be made
to your specification)
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0034
~15
~70
Ø6,8
Angle-Thermocouple
Type : WBT-KP 19
~R=10
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,8/ 5/ 8 mm (VA)
installation depth
: A, B+C to customer
bayonet cap
: MS 58 nickel-plated
C
Ø12.8 (o.n. Angabe)
(your specification)
B
Ø8
A
Ø5
compression spring : V2A
kink protection:
spring
Ø3,8
Maße für A, B, C
nach Angabe
(dimension f. A,B,C to be
made to your specification)
V2A
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0035
Angle-Thermocouple
Type : WT-NH 20
Ø6,8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm
installation depth
: ca. 12 - 19 mm incl. thread
nipple
: MS 58 nickel-plated
70
compression spring : V2A
kink protection:
spring
Ø5
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
M 8x1
Ø6
~17
controll point
~R=10
SW 10
Ø4
V2A
14
20
Other customer preferences are possible
Subject to modifications!
25/03
~30
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0036
Melt-Thermocouple
Type : MAT-H 22
Ø7,8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm / hemispherical
embedded in cement
or keramic
shaft length
: L to customer
screw-in
: thread M 18 x 1,5
Material 1.4305
SW 19
SW 19
kink protection:
spring
M 18x1,5
45°
Ø16
V2A
thermowell
: Material 1.4571
cone seal
measuring insert
: Material 1.4571 / 1.4305
pressure
: to max. 1200 kp/cm²
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
-0,1
Other customer preferences are possible
Subject to modifications!
Ø18
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0037
Surface-Thermocouple
Type : FT-23
Ø5
6
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: contact surface Æ 12 mm (Ms)
mounting hole
hole
: Æ 5 mm (or to customer)
controll point
: soldered
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized iron
wires
Ø5
5
12
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0038
11
Thermocouple
Type : T-NH 25
Ø5
7,5 2,5
8
SW 10
M6
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3/ 4,5 mm (VA)
installation depth
: ca. 11 to 18 mm incl. thread
nipple
: Ms 58 nickel-plated
controll point
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø4,5
Other customer preferences are possible
Subject to modifications!
Ø3
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0040
Thermocouple
Type : BT-VSP 27
Special features:
-
all-purpose in drill holes with the following
front edge: a) 118°, b) plane
-
ceramic insulation of the measuring point against
heat dissipation outward
Ø8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (Ms)
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
~195
Ø 14,8 (o.n. Angabe) *
Ø14 (o.n. Angabe)
*
SW 17 (o.n. Angabe) *
Gewinde nach Angabe *
thread
compression spring : V2A
* = (your specification)
controll point
: ceramic insulated/
118° drill angle/ plane
operation
temperature
: to max. 400°C
Ø6
10
Ø8
2
8
Ø8
118°
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0041
ClampThermocouple
Type : RT-O
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
controll point
: soldered
operation
temperature
: to max. 400°C
Ø
yo na
ur ch
sp An
ec ga
ific be
at
ion
thermoelectric
voltages
Ø5
Standard version:
diameter
width
from
to
16 mm
27 mm
9 mm
20 mm
32 mm
9 mm
32 mm
50 mm
9 mm
50 mm
70 mm
9 mm
70 mm
90 mm
9 mm
90 mm
110 mm
9 mm
110 mm
130 mm
9 mm
Other customer preferences are possible
Subject to modifications!
16/08
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0043
Thermocouple
Type : BT-VH 28
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,5/ 6 mm (VA)
installation depth
: ca. 15 to 70 mm
nipple
: Ms 58 nickel-plated
Ø9,7
bayonet cap
: Ms 58nickel-plated
SW 11
compression spring : V2A
Ø6,5
15
Ø12
20
100
Ø10,5
M 10x1
: soldered/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
~1,5
15
3
controll point
Ø3,5
Other customer preferences are possible
Subject to modifications!
Ø6
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0044
Thermocouple
Type : BT-VS 29
Ø6
*
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm (VA)
installation depth
: ca. 15 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58nickel-plated
compression spring : V2A
~195
Ø14,8 (o.n. Angabe)
thermoelectric
voltages
Ø14 (o.n. Angabe)
*
controll point
: welded/ 118° drill angle
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
SW 17 (o. n. Angabe) *
Gewinde nach Angabe *
thread
* = (your specification)
Other customer preferences are possible
Subject to modifications!
12
25/03
Ø6
118°
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0045
Angle-Thermocouple
Type : WT-NSP 31
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm
with titanium turning part
installation depth
: ca. 7 to 9 mm incl. thread
nipple
: Ms 58 nickel-plated
70
Ø6,8
kink protection:
spring
~42
~R=10
SW 10
V2A
controll point
: soldered/ plane/
118° drill angle
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
M 8x1
Ø6
Ø5
1
4
6 4
Other customer preferences are possible
Subject to modifications!
~27
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0046
:
Knickschutzfeder
(kink protection spring)
Melt-sword-Thermocouple
Type : MAT-33
VA2
Ø7,8
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: sword, Material 1.4571
S=10, 15 or 20 mm
shaft length
: L to customer
controll point
: free of potential
screw-in
: thread G ½” 20 UNF - 2A
Material 1.4305
SW 17
~100
thermoelectric
voltage
SW 14
SW 19
Ø 11
kink protection:
spring
measuring insert
: permanently installed
potential-free
mineral insulated-thermocouple
pressure
: standard version
to max. 1200 kp/cm²
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
5
Schnitt
L
A
B
S
6
8
1 x 45°
30
1/2" - 20 UNF - 2A
A
V2A
S = Schwertlänge (length)
S = 10
S = 15
S = 20
B
Ø7,79
Ø10,5
-0,05
Other customer preferences are possible
Subject to modifications!
-0,05
42/13
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0046 A
Melt-sword-Thermocouple
Type : WMAT-33
~100
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: sword, Material 1.4571
S=10, 15 or 20 mm
shaft length
: L to customer
controll point
: free of potential
screw-in
: thread G ½” 20 UNF - 2A
Material 1.4305
SW 17
48
SW 14
Ø6,5
20
SW 19
Ø 11
L
A
5
Schnitt
B
kink protection
spring
measuring insert
: permanently installed
potential-freees
mineral insulated-Thermocouple
pressure
: standard version
to max. 1200 kp/cm²
S
6
8
1 x 45°
30
1/2" - 20 UNF - 2A
A
S = Schwertlänge (length)
S = 10
S = 15
S = 20
B
Ø7,79
Ø10,5
: V2A
operation
temperature
: to max. 400°C
-0,05
-0,05
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Duisbergstraße 2
Postfach 227
elefon
02338 / 9186-0 e-mail
[email protected]
T
Data Sheet 0048
Plug in-Thermocouple
Type : ST-P 34
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,5 mm (VA)
installation depth
: L to customer
controll point
: soldered/ plane
bend protection
: glass fiber - silicone - sleeving
operation
temperature
:
100
Ø5
Knickschutzfeder
kink protection
: 2 x 0,22 mm²
fiber glass insulation
and specially impregnated
wire mesh aus stainless steel
wire
L
thermocouple wire
to max. 400°C
Other customer preferences are possible
Subject to modifications!
31/03
Ø 3,5
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0048 A
Plug in-Thermocouple
Type : ST-LP 34
~100
Ø5
Knickschutzfeder
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,5 mm (VA)
installation depth
: L to customer
mounting bracket
: 15 x 8 mm
Material 1.4301
bend protection
: glass fiber - silicone - sleeving
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,22 mm²
fiber glass insulation
and specially impregnated
wire mesh aus stainless steel
wire
L
kink protection
Ø 3,5
Other customer preferences are possible
Subject to modifications!
Ø4,5
31/03
Ø3,5
7,5
15
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0049
Air-Thermocouple
Type : LT-N 7
SW 17 (o.n. Angabe)
(your specification)
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 8 mm (Ms),
laterally 24 drill holes je Æ 3 mm
installation depth
: 75 mm incl. thread
(or to customer)
nipple
: Ms 58 nickel-plated
controll point
: open
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
Ø3
23
75
98
Gewinde nach Angabe
(your specification)
thermoelectric
voltages
25/03
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0050
Thermocouple
Type : BT-VH 36
Ø8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6,5/ 8 mm (VA)
installation depth
: ca. 20 to 150 mm
(or to customer)
nipple
: Ms 58 nickel-plated
bayonet cap
: Ms 58 nickel-plated
Ø 14,8 (o.n. Angabe) *
~195
compression spring : V2A
Ø14 (o.n. Angabe) *
SW 17 (o.n. Angabe) *
controll point
: welded/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Gewinde nach Angabe *
thread
5 6,5
25
* = (your specification)
Other customer preferences are possible
Subject to modifications!
Ø6,5
25/03
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0051
Thermocouple
Type : T-NP 35
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 6 mm (Ms)
installation depth
: ca. 10 to 180 mm
(or to customer)
Ø6
compression spring : V2A
SW 13
nipple
: Ms 58 nickel-plated
controll point
: free of potential/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,22 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
M 12
Other customer preferences are possible
Subject to modifications!
11/14
Ø6
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0052
23
Clamp-Thermocouple
Type : KLT-O
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
controll point
: soldered
operation
temperature
: to max. 400°C
dimensions
: size D and B to customer
from width 37 mm connection at
the edge (according to drawing)
from width 38 mm connection in
center
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø5
6
be
a
n g tio n
h A ific a
c
na
ec
Ø r sp
u
yo
Other customer preferences are possible
Subject to modifications!
25/03
B
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0055
Clamp-Thermocouple
Type : KLT-P 38
Ø7,8
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5,6 mm/ 6,6 mm conical (Ms),
38 mm long
~100
screw nut to
: Ms 58 nickel-plated
loosening the sensor
kink protection:
spring
controll point
: soldered/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
20
23
SW 14
V2A
M 10x1
38
Other customer preferences are possible
Subject to modifications!
25/03
Ø5,6
Ø6,6
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0057
Angle-Thermocouple
Type : WST-P 40
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 3,8 mm (VA)
installation depth
: 15 mm (or to customer)
controll point
: welded/ plane
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
~ R 10
20
Ø3,8
Ø5
thermoelectric
voltages
Other customer preferences are possible
Subject to modifications!
~15
25/03
15
Ø
2
x
4
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0058
Thermocouple
Type : WMAT-41
~100
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 4 f7 (1.2080 hardened)
installation depth
: 32 mm incl. thread
(or to customer)
nipple
: VA 1.4305
2
7
Ø6,5
20
thermoelectric
voltages
7
SW 14 drehbar
wrench size 14mm (pivotable)
23
kink protection:
spring
V2A
9
45°
controll point
: welded/ hemispherical
operation
temperature
: to max. 400°C
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Ø4 f 7
Ø10
M12 x 1
Other customer preferences are possible
Subject to modifications!
25/03
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0059
VMS-measurement system
with special-mineral
insulated-referenceThermocouple NiCr-Ni
DIN EN 60584, Kl. 1 (K)
(Details see chapter 1)
Patent angemeldet
(Patent pending)
Other customer preferences are possible
Subject to modifications!
31/03
Ø8
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 0060
Thermocouple
Type : BT-KP 42 gS
Ø10
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
sensor tip
: Æ 5/8/10 mm (VA)
installation depth
: ca. 15 to 130 mm
bayonet cap
: Ms 58 nickel-plated
( with dowel inside )
compression spring : V2A
Ø15,5mm
~175
controll point
operation
temperature
: welded / plane
to max. 400°C
:
thermocouple wire
: 2 x 0,35 mm²
fiber glass insulation
and specially impregnated
wire mesh from soft galvanized
iron wires
Other customer preferences are possible
Subject to modifications!
1
5
10
06/11
Ø5
Ø8
Ø10
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 3010
Screw in -Thermocouple
model series : CHS
PG 9
L
Gewinde nach Angabe
(your specification)
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1 (J)
NiCr-Ni DIN EN 60584, Kl. 1 (K)
small connecting
head
: Æ 48 mm
thread
: G 3/8”
G 1/2”
G 3/4”
installation depth
: L to customer incl. thread
immersion sleeve
: Æ to customer (VA)
controll point
: free of potential
measuring
temperature
: depending on version
up to max. 900°C
Other customer preferences are possible
Subject to modifications!
13/07
Ø nach Angabe
(your specification)
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de
Data Sheet 3001/ 3002/ 3003
straight Thermocouple
a
Pg 16
DIN 43729
Material and thermoelectric voltages
according to DIN bzw. DIN EN
and special typ
thermoelectric
voltages
: Fe-CuNi ½ DIN 43710 (L)
Fe-CuNi DIN EN 60584, Kl. 1
(J)
NiCr-Ni DIN EN 60584, Kl. 1
(K)
connecting head
: form A or B from light alloy
thermowell
: L to customer,
material from steel or ceramic
adapter
: from malleable iron, adjustable
accessories
: available on request
Ø9,5
DIN 43734
L
c
Other customer preferences are possible
Subject to modifications!
06/03
b
Dr. Mennicken GmbH
Industrie-Elektronik
Duisbergstraße 2
D-58339 Breckerfeld
Postfach 227
D-58334 Breckerfeld
Telefon
Telefax
02338 / 9186-0
02338 / 9186-40
e-mail
[email protected]
internalt http://www.mennicken.de