Material Safety Data Sheet Attached

CanadaColorsandChemicalsLimited
152KennedyRoadSouth
Brampton,Ontario
Canada
L6W3G4
GeneralInquiryNumber:(905)459Ͳ1232
MaterialSafetyDataSheet
Attached
SAFETY DATA SHEET
Thisproductisdistributedby
CanadaColorsandChemicalsLimited
(905) 459-1232
GeneralInquiry:(416)449Ͳ7750
24HourEmergency:(416)444Ͳ2112
CCC:ProductCode:______________________
CCC:ProductName:______________________________________
+&.1",46-1)0/*$"$*%
1. Identification
Product identifier
Other means of identification
Recommended use
Recommended restrictions
Jempak 1298
Product code: 507 8005
Surfactant
For industrial use only.
Manufacturer/Importer/Supplier/Distributor information
Manufacturer
Company name
JEMPAK GK INC.
Address
1485 Speers Road, Oakville, L6L 2X5, ON
Telephone General
905-827-1123
Emergency phone number
CANUTEC 1-613-996-6666
CHEMTREC 1-800-424-9300
2. Hazard(s) identification
Physical hazards
Health hazards
Not classified.
Environmental hazards
Acute toxicity, oral
Skin corrosion/irritation
Serious eye damage/eye irritation
Carcinogenicity
Hazardous to the aquatic environment, acute
hazard
Hazardous to the aquatic environment, longterm hazard
Not classified.
OSHA defined hazards
Category 4
Category 1
Category 1
Category 1
Category 2
Category 3
Label elements
Signal word
Hazard statement
Prevention
Response
Storage
Disposal
Hazard(s) not otherwise
classified (HNOC)
Supplemental information
Danger
Harmful if swallowed. Causes severe skin burns and eye damage. Causes
serious eye damage. May cause cancer. Toxic to aquatic life. Harmful to aquatic
life with long lasting effects.
Obtain special instructions before use. Do not handle until all safety precautions
have been read and understood. Do not breathe mist or vapor. Wash thoroughly
after handling. Do not eat, drink or smoke when using this product. Avoid release
to the environment. Wear protective gloves/protective clothing/eye protection/face
protection.
If swallowed: Call a poison center/doctor if you feel unwell. If swallowed: Rinse
mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all
contaminated clothing. Rinse skin with water/shower. If inhaled: Remove person
to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with
water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing. Immediately call a poison center/doctor. Specific treatment (see
this label). Wash contaminated clothing before reuse.
Store locked up, in a cool, dry space.
Dispose of contents/container in accordance with local/ regional/ national/
international regulations.
None known.
None.
3. Composition/information on ingredients
Mixtures
Chemical name
Common name and synonyms
Alkyl(C10-16) benzenesulfonic acid
(Alt CAS 27176-87-0; 85536-14-7)
Alkyl Benzene-Ln. (C10-13)
Sulfuric acid
Other components below reportable levels
4. First-aid measures
Inhalation
Skin contact
Eye contact
Ingestion
Most important symptoms/
effects, acute and delayed
Indication of immediate
medical attention and
special treatment needed
General information
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Specific hazards arising from
the chemical
Special protective equipment
and precautions for
firefighters
Fire-fighting equipment/
instructions
Specific methods
General fire hazards
6. Accidental release measures
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
CAS number
68584-22-5
129813-58-7
7664-93-9
%
90 - 100
1 - < 1.5
1-<2
<1
Move to fresh air. Call a physician if symptoms develop or persist.
Take off immediately all contaminated clothing. Rinse skin with water/shower.
Call a physician or poison control center immediately. Chemical burns must be
treated by a physician. Wash contaminated clothing before reuse.
Immediately flush eyes with plenty of water for at least 15 minutes. Remove
contact lenses, if present and easy to do. Continue rinsing. Call a physician or
poison control center immediately.
Call a physician or poison control center immediately. Rinse mouth. Do not
induce vomiting. If vomiting occurs, keep head low so that stomach content
doesn't get into the lungs.
Burning pain and severe corrosive skin damage. Causes serious eye damage.
Symptoms may include stinging, tearing, redness, swelling, and blurred vision.
Permanent eye damage including blindness could result.
Provide general supportive measures and treat symptomatically. Chemical
burns: Flush with water immediately. While flushing, remove clothes which do
not adhere to affected area. Call an ambulance. Continue flushing during
transport to hospital. In case of shortness of breath, give oxygen. Keep victim
warm. Keep victim under observation. Symptoms may be delayed.
IF exposed or concerned: Get medical advice/attention. Ensure that medical
personnel are aware of the material(s) involved, and take precautions to protect
themselves.
Dry chemical, foam, carbon dioxide, water fog.
Water. Do not use water jet as an extinguisher, as this will spread the fire.
During fire, gases hazardous to health may be formed.
Self-contained breathing apparatus and full protective clothing must be worn in
case of fire.
Move containers from fire area if you can do so without risk.
Use standard firefighting procedures and consider the hazards of other involved
materials.
No unusual fire or explosion hazards noted.
Keep unnecessary personnel away. Keep people away from and upwind of
spill/leak. Keep out of low areas. Wear appropriate protective equipment and
clothing during clean-up. Do not breathe mist or vapor. Do not touch damaged
containers or spilled material unless wearing appropriate protective clothing.
Ensure adequate ventilation. Local authorities should be advised if significant
spillages cannot be contained. For personal protection, see section 8 of the
SDS.
Should not be released into the environment.
Large Spills: Stop the flow of material, if this is without risk. Dike the spilled
material, where this is possible. Cover with plastic sheet to prevent spreading.
Absorb in vermiculite, dry sand or earth and place into containers. Prevent
Environmental precautions
7. Handling and storage
Precautions for safe handling
Conditions for safe storage,
including any incompatibilities
entry into waterways, sewer, basements or confined areas. Following product
recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean
surface thoroughly to remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see
section 13 of the SDS.
Avoid release to the environment. Contact local authorities in case of spillage
to drain/aquatic environment. Prevent further leakage or spillage if safe to do
so. Do not contaminate water. Avoid discharge into drains, water courses or
onto the ground.
Obtain special instructions before use. Do not handle until all safety
precautions have been read and understood. Do not breathe mist or vapor.
Do not get this material in contact with eyes. Do not get this material in
contact with skin. Do not taste or swallow. Avoid prolonged exposure. Do not
get this material on clothing. Provide adequate ventilation. Wear appropriate
personal protective equipment. Observe good industrial hygiene practices.
When using, do not eat, drink or smoke. Wash hands thoroughly after
handling. Wash contaminated clothing before reuse. Avoid release to the
environment. Do not empty into drains.
Store locked up. Store in original tightly closed container. Store away from
incompatible materials (see Section 10 of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
Components
Type
Value
Sulfuric acid (CAS 7664-93-9)
PEL
1 mg/m3
US. ACGIH Threshold Limit Values
Components
Type
Value
Sulfuric acid (CAS 7664-93-9)
TWA
0.2 mg/m3
US. NIOSH: Pocket Guide to Chemical Hazards
Components
Type
Value
Sulfuric acid (CAS 7664-93-9)
TWA
1 mg/m3
Biological limit values
Appropriate engineering
controls
Form
Thoracic fraction.
No biological exposure limits noted for the ingredient(s).
Good general ventilation (typically 10 air changes per hour) should be used.
Ventilation rates should be matched to conditions. If applicable, use process
enclosures, local exhaust ventilation, or other engineering controls to
maintain airborne levels below recommended exposure limits. If exposure
limits have not been established, maintain airborne levels to an acceptable
level. Eye wash facilities and emergency shower must be available when
handling this product.
Individual protection measures, such as personal protective equipment
Eye/face protection
Wear eye/face protection. Wear safety glasses with side shields (or
goggles) and a face shield.
Hand protection
Wear appropriate chemical resistant gloves.
Skin protection
Other
Wear appropriate chemical resistant clothing. Wear protective gloves.
Respiratory protection
In case of insufficient ventilation, wear suitable respiratory equipment.
Thermal hazards
Wear appropriate thermal protective clothing, when necessary.
General hygiene considerations
When using, do not eat, drink or smoke. Always observe good personal
hygiene measures, such as washing after handling the material and before
eating, drinking, and/or smoking. Routinely wash work clothing and
protective equipment to remove contaminants.
9. Physical and chemical properties
Appearance
Physical state
Liquid.
Form
Viscous. Liquid.
Color
Dark amber.
Odor
Not available.
Odor threshold
Not available.
pH
< 1.0 as is
Melting point/freezing point
-0.4 °F (-18 °C)
Initial boiling point and boiling
> 212 °F (> 100 °C)
Range
Flash point
> 201 °F (> 93.9 °C)
Evaporation rate
Estimated slower than ethyl ether.
Flammability (solid, gas)
Not available.
Upper/lower flammability or explosive limits
Flammability limit – lower (%)
Not available
Flammability limit – upper (%)
Not applicable
Explosive limit - lower (%)
Not available
Explosive limit - upper (%)
Not available
Vapor pressure
Not Determined or Unknown
Vapor density
Estimated heavier than air
Relative density
Not available
Solubility(ies)
Solubility (water)
Not available
Auto-ignition temperature
Not available
Decomposition temperature
Not available
Viscosity
5100 SUS @ 100 °F
Other information
Density
Not available
Pour point
5 °F (-15 °C)
Specific gravity
< 1.06 (water = 1)
10. Stability and reactivity
Reactivity
Chemical stability
Possibility of hazardous
reactions
Conditions to avoid
Incompatible materials
Hazardous decomposition
products
The product is stable and non-reactive under normal conditions of use,
storage and transport.
Material is stable under normal conditions.
No dangerous reaction known under conditions of normal use.
Heat, flames and sparks. Reacts violently with strong alkaline substances.
This product may react with reducing agents. Contact with incompatible
materials.
This product may react with reducing agents. Incompatible with bases.
Upon decomposition, this product may yield sulfur dioxide and oxides of
sulfur.
11. Toxicological information
Information on likely routes of exposure
Ingestion
Causes digestive tract burns. Harmful if swallowed.
Inhalation
Prolonged inhalation may be harmful. May cause irritation to the respiratory
system.
Skin contact
Causes severe skin burns. May be harmful in contact with skin.
Eye contact
Causes serious eye damage
Symptoms related to the
Burning pain and severe corrosive skin damage. Causes serious eye
physical, chemical and
damage. Symptoms may include stinging, tearing, redness, swelling, and
toxicological characteristics
blurred vision. Permanent eye damage including blindness could result.
Information on toxicological effects
Acute toxicity
Harmful if swallowed. May be harmful in contact with skin.
Product
JEMPAK 1298
Acute
Dermal LD50
Oral LD50
Species
Test Results
Rabbit
Rat
> 2000 mg/kg
500 - 2000 mg/kg
Skin corrosion/irritation
Serious eye damage/eye irritation
Respiratory or skin sensitization
Respiratory sensitization
Skin sensitization
Germ cell mutagenicity
Causes severe skin burns and eye damage.
Causes serious eye damage
Not available.
This product is not expected to cause skin sensitization
No data available to indicate product or any components present at greater
than 0.1% are mutagenic or genotoxic
Carcinogenicity
May cause cancer. IARC Category 1: Strong inorganic acid mists
containing sulfuric acid.
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
Reproductive toxicity
This product is not expected to cause reproductive or developmental
effects
Specific target organ toxicity
Not applicable.
single exposure
Specific target organ toxicity
Not applicable.
repeated exposure
Aspiration hazard
Not applicable
12. Ecological information
Ecotoxicity
Product
Species
JEMPAK 1298
Algae EC50
Algae
Crustacea EC50
Daphnia
Fish LC50
Fish
Persistence and degradability
Bioaccumulative potential
Mobility in soil
Other adverse effects
13. Disposal considerations
Disposal instructions
Hazardous waste code
Waste from residues / unused
products
Contaminated packaging
14. Transport information
DOT
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
Special precautions for user
Toxic to aquatic life. Harmful to aquatic life with long lasting effects.
Test Results
47.3 mg/l, 72 hours
2.4 mg/l, 48 hours
1.67 mg/l, 96 hours
Readily biodegradable.
No data available.
No data available.
No other adverse environmental effects (e.g. ozone depletion,
photochemical ozone creation potential, endocrine disruption, global
warming potential) are expected from this component.
Dispose of contents/container in accordance with local/ regional/ national/
international regulations.
The waste code should be assigned in discussion between the user, the
producer and the waste disposal company.
Dispose of in accordance with local regulations. Empty containers or liners
may retain some product residues. This material and its container must be
disposed of in a safe manner (see: Disposal instructions).
Empty containers should be taken to an approved waste handling site for
recycling or disposal. Since emptied containers may retain product residue,
follow label warnings even after container is emptied.
UN2586
ARYLSULFONIC ACIDS, LIQUID with not more than 5 per cent free
sulfuric acid
8
III
Read safety instructions, SDS and emergency procedures before handling
IATA
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
Environmental hazard
Special precautions for user
IMDG
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
Environmental hazard
Marine pollutant
EmS
Special precautions for user
Transport in bulk according to
Annex II of MARPOL 73/78 and
the IBC Code
UN2586
ARYLSULFONIC ACIDS, LIQUID with not more than 5 per cent free
sulfuric acid
8
III
No
Read safety instructions, SDS and emergency procedures before handling
UN2586
ARYLSULFONIC ACIDS, LIQUID with not more than 5 per cent free
sulfuric acid
8
III
No
Not available
Read safety instructions, SDS and emergency procedures before handling
Not available
DOT
IATA; IMDG
15. Regulatory information
US federal regulations
This product is a "Hazardous Chemical" as defined by the OSHA Hazard
Communication Standard, 29 CFR 1910.1200.
CERCLA Hazardous Substance List (40 CFR 302.4)
Sulfuric acid (CAS 7664-93-9)
Listed.
US EPCRA Section 304 Extremely Haz. Subs. & CERCLA Haz. Subs.: Section 304 EHS reportable quantity
Sulfuric acid (CAS 7664-93-9)
1000 lbs
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Hazard categories
Immediate Hazard - Yes
Delayed Hazard - Yes
Fire Hazard - No
Pressure Hazard - No
SARA 302 Extremely hazardous
substance
SARA 311/312 Hazardous
chemical
SARA 313 (TRI reporting)
Chemical mane
Sulfuric acid
Reactivity Hazard - No
No
Yes
CAS number
7664-93-9
% by wt.
1-<2
Other federal regulations
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Clean Water Act (CWA) Section 112(r) (40 CFR 68.130)
Hazardous substance
Safe Drinking Water Act (SDWA)
Not regulated
Drug Enforcement Administration (DEA). List 2, Essential Chemicals (21 CFR 1310.02(b) and 1310.04(f)(2) and
Chemical Code Number
Sulfuric acid (CAS 7664-93-9)
6552
Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c))
Sulfuric acid (CAS 7664-93-9)
20 % weight/ volume
DEA Exempt Chemical Mixtures Code Number
Sulfuric acid (CAS 7664-93-9)
6552
US state regulations
WARNING: This product may contain a chemical known to the State of
California to cause cancer and birth defects or other reproductive harm.
Strong inorganic mists containing sulfuric acid (if customers intended use
generates an acid mist)
US - New Jersey Community RTK (EHS Survey): Reportable threshold
Sulfuric acid (CAS 7664-93-9)
500 lbs
US - Pennsylvania RTK - Hazardous Substances: Listed substance
Sulfuric acid (CAS 7664-93-9)
US. Massachusetts RTK - Substance List
Sulfuric acid (CAS 7664-93-9)
US. Rhode Island RTK
Sulfuric acid (CAS 7664-93-9)
US. California Proposition 65
WARNING: This product may contain a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm. Strong inorganic mists containing sulfuric acid (if customers intended use generates an acid
mist)
WARNING: This product contains a chemical known to the State of California to cause birth defects or other
reproductive harm.
US - California Proposition 65 - CRT: Listed date/Developmental toxin
Sulfur dioxide (CAS 7446-09-5)
Listed: July 29, 2011
International Inventories
Country(s) or region
Australia
Canada
Canada
China
Europe
Europe
Japan
Korea
New Zealand
Philippines
Inventory name
On inventory (yes/no)*
Australian Inventory of Chemical Substances (AICS)
Yes
Domestic Substances List (DSL)
Yes
Non-Domestic Substances List (NDSL)
No
Inventory of Existing Chemical Substances in China (IECSC) Yes
European Inventory of Existing Commercial Chemical
Yes
Substances (EINECS)
European List of Notified Chemical Substances (ELINCS)
No
Inventory of Existing and New Chemical Substances (ENCS) Yes
Existing Chemicals List (ECL)
Yes
New Zealand Inventory
Yes
Philippine Inventory of Chemicals and Chemical Substances Yes
(PICCS)
United States & Puerto Rico
Toxic Substances Control Act (TSCA) Inventory
Yes
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the
governing country(s)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory
administered by the governing country(s).
16. Other information, including date of preparation or last revision
Issue date
06-01-2015
Revision date 06-01-2015
Version
01
NFPA ratings
DISCLAMER
This SDS is designed only as guidance for the products to which it applies. We believe the statements, technical
information and recommendations contained herein are reliable, but they are given without warranty or guarantee of
any kind, express or implied, and we assume no responsibility for any loss, damage, or expense, direct or
consequential, arising out of their use. There is no warranty, expressed or implied, as to the accuracy, completeness
or adequacy of the information contained herein, and neither the provider nor the manufacturer (nor the agents,
directors, officers, contractors or employees of either) are liable to any party for any damages of any nature, including
direct, special or consequential damages arising out of or in connection with the accuracy, completeness, adequacy
or furnishing of any information in this SDS, or in any other way related (directly or indirectly) to this SDS. The receipt
and use of this information constitutes consent to these terms and conditions.