SAFETY DATA SHEET – Gorilla Shipping Tape

Transcription

Date Revised: September 1, 2014 1st Edition
FOR CHEMICAL EMERGENCY:
During Business Hours: (800) 966-3458 | Outside Business Hours: (800) 420-7186
SECTION 1. Identification
Product Identifier
Product Name:
Gorilla Shipping Tape
Synonyms:
None
Intended Use of the Product
Packaging / Shipping Tape
Name, Address, and Telephone of the Responsible Party
The Gorilla Glue Company
4550 Red Bank Expressway
Cincinnati, Ohio 45227
513-271-3300
www.gorillatough.com
Emergency Telephone Number
Emergency Number: 1-800-420-7186 (Prosar)
SECTION 2. Hazards Identification
Classification of the substance or mixture
Not classified.
Label Elements
No labelling applicable.
Other Hazards
Not available.
Unknown Acute Toxicity (GHS-US)
Not available.
SECTION 3. Composition / information on Ingredients
Mixture
Component
Polypropylene
Acrylic Adhesive
Silicone
Solvent
GORILLA SHIPPING TAPE
CAS Number
9003-07-0
Trade Secret
Trade Secret
141-78-6
%
60-75
20-30
<1
<1
Page 1 of 6
SECTION 4. First Aid Measures
Description of first aid measures
General: In all cases of doubt, or when symptoms persist, seek medical advice/attention. Bring the
Safety Data Sheet or label on the dispenser / package. Never give anything by mouth to an unconscious
person.
Inhalation: Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped,
administer artificial respiration. Give nothing by mouth. If unconscious place the person in
the recovery position. Seek medical attention.
Skin Contact: Immediately wash skin thoroughly with plenty of warm water and soap and follow up by
rinsing with water for at least 15 minutes. Call a Poison Center or seek medical attention if
you feel unwell. Remove contaminated clothing and wash before reuse.
Eye Contact: Immediately flush eyes with water for at least 10 minutes. If shipping tape is adhered to
the eye lid, gentle and slowly roll tape back off lid, if possible. Do not attempt to pull away
from eye’s cornea. Seek medical attention.
Ingestion:
Do not induce vomiting and ensure the passageway is not blocked. Seek medical attention.
Most important symptom and effects, both acute and delayed
General:
May cause slight irritation
Inhalation: May cause slight irritation
Skin Contact: May cause slight irritation
Eye Contact: May cause slight irritation
Ingestion:
Ingestion may be harmful or have adverse effects
Chronic Symptoms: Not Applicable
Indication of any immediate medical attention and special treatment needed
If medical advice is needed, have product container or label at hand.
SECTION 5. Firefighting Measures
Extinguishing media
Suitable extinguishing media:
Unsuitable extinguishing media:
Use extinguishing media appropriate for surrounding fire.
Do not use a heavy stream of water. Use of a heavy stream of water
may spread fire.
Special hazards arising from the substance or mixture
Fire Hazard:
Not flammable under stable conditions.
Explosion Hazard:
Product is not explosive.
Reactivity:
Hazardous reactions will not occur under normal conditions.
Page 2 of 6
Advice for firefighters
Precautionary Measures Fire:
Firefighting Instructions:
Protection During Firefighting:
Hazardous Combustion Products:
Exercise caution when fighting any chemical fire.
Do not allow run-off from firefighting to enter drains/water courses.
Do not enter fire area without the proper protective equipment,
including respiratory protection.
None known.
Reference to Other Sections
Refer to Section 9 for flammability properties.
SECTION 6. Accidental Release Measures
Personal precautions, protective equipment and emergency procedures
Avoid contact with skin, eyes and clothing.
For Non-Emergency Personnel
Protective Equipment:
Use appropriate personal equipment (PPE) when necessary.
Emergency Procedures:
Evacuate unnecessary personnel.
For Emergency Personnel
Protective Equipment:
Equip cleanup crew with the proper protection.
Emergency Procedures:
Keep area ventilated.
Environmental precautions
Do not allow product to enter drains or watercourses.
Methods and material for containment and cleaning up
For Containment:
No specific measures are necessary.
Methods for Cleaning up: Dispose of waste safely and in accordance with local, state, and federal
regulations.
Reference to other sections
See Section 8 for Exposure Control and Personal Protection.
See Section 13 for Disposal Considerations.
SECTION 7. Handling and Storage
Precautions for safe handling
Hygiene Measures:
Handle in accordance with good industrial hygiene and safety procedures.
Wash hands and other exposed areas with mild soap and water before
eating, drinking or working.
Conditions for safe storage, including any incompatibilities
Storage Conditions:
Store in a dry, cool and well ventilated place. Store away from heat.
Incompatible Materials:
None known.
Maximum Storage Period: Varies depending on storage conditions.
Page 3 of 6
Specific end use(s)
Tape
SECTION 8. Exposure controls / personal protection
Control parameters
Component
CAS Number
Solvent
141-78-6
OSHA – Occupational Safety and Health Administration
PEL – Permissible Exposure Limit
OSHA PEL
400 ppm
ppm – Parts per Million
Exposure controls
Appropriate Engineering Controls: Emergency eye wash fountains and safety showers should be
available in the immediate vicinity of any potential exposure. Provide
sufficient ventilation. Ensure all national/local regulations are observed.
Personal Protective Equipment:
Gloves. Safety Glasses.
Materials for Protective Clothing: Chemical resistant materials and fabrics are recommended, but not
required.
Hand Protection:
Chemical resistant gloves are recommended, but not required.
Eye Protection:
Chemical goggles or safety glasses.
Skin and Body Protection: Wear suitable protective clothing.
Respiratory Protection:
Use a NIOSH approved respirator or self-contained breathing apparatus
when needed.
Other Information:
When using, do not eat, drink or smoke.
SECTION 9. Physical and Chemical Properties
Physical State
Color
Odor
Odor Threshold
Boiling Range/Point (°C/F)
Flash Point (PMCC) (°C/F)
Evaporation Rate (BuAc=1)
Vapor Density (Air = 1)
VOC (g/l)
VOC (%)
Partition Coefficient
(n-octanol/water)
Solubility in Water
Solid
Clear
Slight, Sour
No data available
No data available
No data available
No data available
No data available
No data available
No data available
Not applicable
pH
Density (g/l, g/yd2)
Specific Gravity
Melting Point (°C/F)
Vapor Pressure
Flammability (solid / gas)
Viscosity
Auto-Ignition Temperature
Decomposition Temperature
Upper Explosive Limit
Lower Explosive Limit
No data available
No data available
No data available
Not applicable
No data available
Not applicable
No data available
No data available
No data available
Not applicable
Not applicable
Non-soluble
Page 4 of 6
SECTION 10. Stability and Reactivity
Reactivity:
None known.
Chemical stability:
Stable when stored and handled correctly (see Section 7).
Possibility of hazardous reactions: Hazardous polymerization will not occur.
Conditions to avoid:
Avoid heat and open flames.
Incompatible materials:
None known.
Hazardous decomposition products: Carbon oxides (CO, CO2), Nitrogen Oxides.
SECTION 11. Toxicological Information
Information on toxicological effects
Acute Toxicity:
Not Available
LD50 and LC50:
Not Available
Skin Corrosion/Irritation:
Not Available
Serious Eye Damage/Irritation:
Not Available
Respiratory or Skin Sensitization:
Not Available
Germ Cell Mutagenicity:
Not Available
Teratogenicity:
Not Available
Carcinogenicity:
Not Available
Specific Target Organ Toxicity (Repeated Exposure):
Not Available
Specific Target Organ Toxicity (Single Exposure):
Not Available
Reproductive Toxicity:
Not Available
Aspiration Hazards
Not Available
Inhalation:
None expected under normal use.
Skin Contact:
May cause mild skin irritation.
Eye Contact:
May cause mild eye irritation.
Ingestion:
Ingestion may be harmful or have adverse effects.
Chronic Symptoms:
Not Applicable
SECTION 12. Ecological Information
Toxicity:
Persistence and degradability:
Bioaccumulative potential:
Mobility in soil:
Other adverse effects:
Not Available
Not Available
Not Available
Not Available
Avoid release into the environment.
Page 5 of 6
SECTION 13. Disposal Considerations
Waste disposal recommendations: Dispose of waste material in accordance with all local, regional,
national, provincial, territorial, and international regulations.
SECTION 14. Transportation information
Department of transportation (DOT):
Not regulated for transport
Marine transport (IMDG):
International Air transport (IATA):
Transportation of Dangerous Goods (TDG - Canada):
Mexico Transport:
SECTION 15. Regulatory information
US Federal Regulations
Toxic Substance Control Act
All components of this product are in compliance with the inventory listing requirements of the US
Toxic Substance Control Act (TSCA) Chemical Substance Inventory.
US State Regulations
California Proposition 65
The following statement is made in order to comply with the California Safe Drinking Water and
Toxic Enforcement Act of 1986:
To the best of our knowledge, this product does not contain Proposition 65 Chemicals at
levels which would require warning labels as known to the State of California to cause
cancer or reproductive toxicity.
Massachusetts, New Jersey or Pennsylvania Right to Know Substance List
Component
CAS Number
%
Solvent
141-78-6
<1
SECTION 16. Other information
The information presented in this Safety Data Sheet was prepared by qualified personnel and to the best
of our knowledge is true and accurate. The information and recommendations are furnished for this
product with the understanding that the purchaser will independently determine the suitability of the
product for this purpose. This data does not constitute a warranty, expressed or implied, statutory or
otherwise, nor is it representation for which The Gorilla Glue Company assumes legal responsibility. The
data is submitted for the user’s information and consideration only. Any use or disposal of this product
must be determined by the user to be in accordance with applicable federal, state, provincial and local
laws and regulations.
Page 6 of 6

SAFETY DATA SHEET – Gorilla Shipping Tape

Transcription

Similar documents