SL4635/4835 Skid Steer Loaders

Transcription

Form No.
®
SL4635/4835
Skid Steer
Loaders
907807
PARTS BOOK
Introduction
For your safety and continued proper operation, use
only genuine GEHL® service parts. When ordering
service parts, specify the correct part number, full
description, quantity required, the unit model number
and serial number.
The model and serial numbers for this unit are on a
decal located inside the right chassis riser, between
the lift arm and inner riser. “Right” and “Left” are
determined from a position sitting on the seat and
facing forward.
GEHL Company reserves the right to make changes
or improvements in the design or construction of any
part of the unit without incurring the obligation to
install such changes on any previously delivered
units.
NOTE: The following abbreviations may be
used herein:
AMP . . . . . . . Ampere
AR . . . . . . . . As Required
ASSY . . . . . . Assembly
CCA . . . . . . . Cold Cranking Amperage
CYL . . . . . . . Cylinder
FRT . . . . . . . Front
FL . . . . . . . . Flare
GA . . . . . . . . Gauge
HEX . . . . . . . Hexagon
JIC . . . . . . . . Joint Industrial Council
kW . . . . . . . . Kilowatt
LBS . . . . . . . Pounds
LT . . . . . . . . Left
NOTE: Purchase equivalent, quality tires for
your loader. Contact your dealer for replacement
tire information.
M. . . . . . . . . Metric
NOTE: Replacement batteries are not provided by the GEHL Company. For battery specifications see pages titled “Electrical Engine
Harness/Battery”. ALL REPLACEMENT BATTERIES MUST BE PURCHASED LOCALLY.
N/A . . . . . . . Not Applicable
Refer to the abbreviations table located on this page
for the various fastener descriptions. Standard
attaching hardware torque values are also provided
on the inside back cover. If a part requires
lubrication or a nonstandard torque value, it will
be specified behind the part number description
in parenthesis.
Items shown in the parts list that do not have part
numbers are shown for reference purposes only and
are NOT available for purchase.
Dimensions are in inches unless otherwise
specified.
MM (mm) . . . . Millimeter
NA . . . . . . . . Naturally Aspirated
NEG . . . . . . . Negative
NILN. . . . . . . Nylon Insert Lock Nut
NO . . . . . . . . Number
NPT . . . . . . . National Pipe Thread
OPER . . . . . . Operator
POS . . . . . . . Positive
PSI . . . . . . . . Pounds per Square Inch
QTY . . . . . . . Quantity
REF . . . . . . . Reference
REQ’D . . . . . . Required
ROPS . . . . . . Roll Over Protective Structure
RPM . . . . . . . Revolutions Per Minute
RT . . . . . . . . Right
SAE . . . . . . . Society of Automotive Engineers
SN . . . . . . . . Serial Number
SQ . . . . . . . . Square
ST . . . . . . . . Straight
TURBO . . . . . Turbocharger
V . . . . . . . . . Volt
GEHL is a registered trademark of the Gehl Company.
TABLE OF CONTENTS
DESCRIPTION
PAGE
SECTION A: MAIN LOADER COMPONENTS
Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Wheel Drives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Air Cleaner and Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Oil Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydrostatic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Hydraulics - Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Hydraulics - Chassis - Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Hydraulics - Lift Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Auxiliary Hydraulic Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Controls - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Controls - Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Controls - Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Lift Arm and All-Tach™ Attachment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
ROPS and Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Restraint Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Sound Suppression . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Grille and Engine Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Electrical - Instrument Panel/Harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Electrical - Engine Harness/Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Electrical - Lights. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Decals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
SECTION B: HYDRAULIC COMPONENTS
Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Drive Motor and Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tandem Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Gear Pump - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Gear Pump - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Self-Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Solenoid Valves - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Solenoid Valve - Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Valve - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
(continued on next page)
All-Tach is a trademark of the Gehl Company.
TABLE OF CONTENTS
DESCRIPTION
PAGE
SECTION C: ACCESSORIES
Backhoe Mount Kit 807184 . . . . . . . . . . . . . . . . . .
Crossmember Auxiliary Tube Kit 807233 . . . . . . . . . .
Backhoe Hydraulics Kit 807193 (4635) and 807231 (4835) .
All-Tach Kit 807825. . . . . . . . . . . . . . . . . . . . . .
4635 T-Bar and Dual Hand Auxiliary Hydraulics Kit 807239
Frame Reinforcement Kit 807238 . . . . . . . . . . . . . . .
Rear Counterweight Kit 807243. . . . . . . . . . . . . . . .
Gehl Quick-Tach™ Kit 807230 . . . . . . . . . . . . . . . .
Backhoe 1/2 Mount for 9HD2 Backhoe Kit 806293 . . . . .
Rearview Mirror Kit 806894 . . . . . . . . . . . . . . . . .
Backup Alarm Kit 807190. . . . . . . . . . . . . . . . . . .
Cab Heater Kit 807824 . . . . . . . . . . . . . . . . . . . .
Dome Light Kit 807278 . . . . . . . . . . . . . . . . . . . .
Horn Kit 806923. . . . . . . . . . . . . . . . . . . . . . . .
Centrifugal Pre-Cleaner Kit 808204. . . . . . . . . . . . . .
Parker Coupler Kit 807050 . . . . . . . . . . . . . . . . . .
Engine Auto Shutdown System Kit 806918. . . . . . . . . .
Strobe Light Kit 805803 . . . . . . . . . . . . . . . . . . . .
Dual Flasher Kit 806920. . . . . . . . . . . . . . . . . . . .
Front Door Kit 807292 . . . . . . . . . . . . . . . . . . . .
Airboss Solid Segmented Tire Repair Parts . . . . . . . . . .
Self-Level Valve Kit 807336 . . . . . . . . . . . . . . . . .
Double Gas Spring Kit 807376 . . . . . . . . . . . . . . . .
Tilt Cylinder Lock Valve Kit 135564 . . . . . . . . . . . . .
Impact Resistant Front Door Kit 807330 . . . . . . . . . . .
Work Taillight Kit 807293 . . . . . . . . . . . . . . . . . .
Deluxe Interior Kit 807429 . . . . . . . . . . . . . . . . . .
Side-Mounted Cab Heater Kit 807833 . . . . . . . . . . . .
Other Accessories . . . . . . . . . . . . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
109
109
110
110
111
112
112
113
114
114
115
116
117
118
118
119
119
120
120
121
122
122
123
123
124
124
125
126
127
Numerical Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
O-Ring Table, Coupling & Adapter Torque Table . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Torque Specifications Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inside Back Cover
Quick-Tach is a trademark of the Gehl Company.
Spiralock is a trademark of H.D. Holmes, licensed to Detroit Tool Industries.
License includes U.S. and foreign patent rights. Loctite is a registered trademark of the Loctite Corporation.
Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Wheel Drives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Air Cleaner and Muffler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Oil Cooler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Hydrostatic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Hydraulics - Chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Hydraulics - Chassis - Main Control Valve . . . . . . . . . . . . . . . . . . . . 21
Hydraulics - Lift Arm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Auxiliary Hydraulic Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Controls - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Controls - Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Controls - Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Lift Arm and All-Tach™ Attachment System . . . . . . . . . . . . . . . . . . . 53
ROPS and Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Restraint Bar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Sound Suppression . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Grille and Engine Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Electrical - Instrument Panel/Harness . . . . . . . . . . . . . . . . . . . . . . . 67
Electrical - Engine Harness/Battery . . . . . . . . . . . . . . . . . . . . . . . . 69
Electrical - Lights. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Decals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
SL46/4835 SKID LOADERS - CHASSIS
50
51
51
24
2
50
25
Hand & Foot Controls
Hand Controls
15
23
16
21
20
5
22
4
6
8
1
3
13
4
9
7
18
17
12
14
10
11
134066x1.cpt
907807/HP1002
1
PRINTED IN USA
SL46/4835 SKID LOADERS - CHASSIS
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
20
21
22
23
24
25
Ref.
No.
50
51
Part
No.
134201
134331
135838
650495
134853
072343
136244
650687
131842
134558
651041
134756
134299
651041
135270
136013
651312
134345
651041
131830
650453
654030
134427
134426
650453
654030
660080
131522
135293
128591
127342
650494
654046
132298
132050
650702
132051
134824
650488
135814
136201
650486
131842
136202
Part
No.
134694
135247
651041
135006
134536
135090
134548
651041
134852
PRINTED IN USA
Quantity
4635
Description
ASSEMBLY/CHASSIS
ASSEMBLY/CHASSIS
PLATE/CROSSMEMBER
SCREW/CAP HEX HEAD 1/2 X 1-1/4
NUT/SPIRALOCK™ 1/2
GASKET/FUEL SENDER (Hi-Tack Gasket Adhesive)
PANEL ASSEMBLY/CHASSIS
BOLT/CARRIAGE 5/16 X 3/4
COVER ASSEMBLY/RESERVOIR (Oil-resistant RTV)
SCREW/MACHINE HEX WASHER HEAD 3/8 X 3/4
SIGHT PORT/OIL LEVEL (Loctite® 290)
COVER ASSEMBLY/CHAINCASE (Oil-resistant RTV)
WASHER/SEALING 3/8
SENSOR/FUEL
SCREW/MACHINE PHILLIPS HEAD #10 X 1/2
COVER/TOE PLATE
PLATE/FLOOR SHORT
WASHER/LOCK 1/2
PLATE-FLOOR LONG
PLATE-FLOOR LONG
WASHER/LOCK 1/2
PLUG/PIPE 3/4 (Pipe Thread Sealant)
PLUG SAE12
BOLT/WHEEL LUG
BREATHER/HYDRAULIC RESERVOIR
CAP/HYDRAULIC RESERVOIR
SCREW/CAP HEX HEAD 1/2 X 1
WASHER/PLAIN 7/16
SEAL/WASHER 1/2
STRAINER/FUEL FILL
SCREW/MACHINE PHILLIPS HEAD #6 X 3/8
CAP/FUEL FILL
TRAY ASSEMBLY/BATTERY
SCREW/CAP HEX HEAD 3/8 X 3/4
LOCK/RUBBER 20-1/2
FILLER/RIGHT CROSSMEMBER
SCREW/CAP 5/16 X 3/4
NUT/SPIRALOCK 5/16
FILLER/LEFT CROSSMEMBER
1
1
6
6
1
2
4
4
1
6
1
2
16
2
1
5
1
3
1
2
2
1
2
2
2
2
40
1
1
4
4
4
1
1
1
1
3
1
1
1
1
1
Quantity
Dual Hand & T-Bar
Description
COVER/CONTROL
COVER/CONTROL
FLOOR ASSEMBLY/FRONT (4635 Dual Hand & T-Bar Model)
FLOOR ASSEMBLY/FRONT (4835 Dual Hand & T-Bar Model)
FLOOR ASSEMBLY/FRONT (4635 H/F Model)
FLOOR ASSEMBLY/FRONT (4835 H/F Model)
2
1
2
1
1
2
2
Quantity
4835
1
1
6
6
1
2
4
4
1
6
1
2
16
2
1
5
1
3
1
2
2
1
2
2
2
2
40
1
1
4
4
4
1
1
1
1
3
1
1
1
1
1
Quantity
Hand & Foot
1
2
1
1
2
2
907807/HP1002
SL46/4835 SKID LOADERS - WHEEL DRIVES
14
16
16
3
19
4
24
2
3
8
6
9
10
11
22
19
12
7
7
4
5
5
9
8
11
22
13
6
2
10
13
Right Side Wheel Drive
1
12
16
23
15
11
13
16
12
22
1
5
7
2
19
13
10
10
12
6
6
9
3
11
8
22
8
5
7
Left Side Wheel Drive
4
4
2
19
9
134632x.cpt
3
907807/HP1002
3
25
PRINTED IN USA
SL46/4835 SKID LOADERS - WHEEL DRIVES
Ref.
No.
Part
No.
Quantity
4635
Description
1
133966a
MOTOR/DRIVE SINGLE SPEED W/ PARKING BRAKE (RTV)
651085
SCREW/CAP HEX HEAD 1/2 X 1-3/4 (90 ft-lbs)
129055
2
135311
HOUSING/AXLE (Oil-resistant RTV)
129055
NUT/SPIRALOCK™ 1/2 (90 ft-lbs)
3
136116
AXLE ASSEMBLY/WHEEL
079152
NUT/WHEEL 5/8 (180 ft-lbs)
133957
BOLT/WHEEL 5/8 X 2
4
131139
SEAL 3 X 4.331
5
083108
BEARING/CONE (Lithium Grease)
6
520013
CUP/BEARING
7
087812
SHIM/BEARING
8
078946
BEARING/CUP
9
078945
BEARING/CONE (Lithium Grease)
10
131663
SPACER/AXLE
11
134230
ASSEMBLY/SPROCKET #80-40T
12
135803
WASHER
13
651381
NUT/HEX SLOTTED 1-1/4 (150 ft-lbs)
650554
PIN/COTTER 1/4 X 2-1/4
14
135143
IDLER ASSEMBLY/RIGHT REAR
651526
079209
NUT/LOCK NYLON INSERT 3/4 (Loctite® 290)
131609
046588
WASHER/FLAT 25/32
15
135142
IDLER ASSEMBLY/LEFT REAR
651526
079209
NUT/LOCK NYLON INSERT 3/4
131609
046588
WASHER/FLAT 25/32
16
132027
TUBE/PIVOT INNER
19
134503
CHAIN/ROLLER #80 X 66
134827
LINK/CONNECTOR
134504
CHAIN/ROLLER #80 X 74
134827
LINK/CONNECTOR
22
131892
SEAL/V-RING (Lithium Grease)
23
135135
IDLER ASSEMBLY/LEFT FRONT
651526
079209
131609
046588
WASHER/FLAT 25/32
24
135136
IDLER ASSEMBLY/RIGHT FRONT
651526
079209
131609
046588
WASHER/FLAT 25/32
25
131083
WHEEL/15 X 6 (YELLOW) (7.5 X 15 TIRE)
122976
WHEEL/16.5 X 9.75 (YELLOW) (12 X 16.5 TIRE)
079157
WHEEL/16.5 X 9.75 (GRAY) (12 X 16.5 TIRE)
122978
WHEEL/15 X 13 (YELLOW) (29 X 12.5 X 15 TIRE)
135465
WHEEL/16.5 X 8.25 (GRAY) (10 X 16.5 TIRE)
134371
134372
128507
STEM/VALVE
a) For breakdown see “Section B” of this manual.
PRINTED IN USA
4
2
20
20
4
40
4
32
32
4
4
4
8
4
4
4
4
8
4
4
1
1
1
3
2
1
1
1
3
2
4
4
4
4
1
1
1
3
2
1
1
1
3
2
4
4
4
4
4
4
4
4
Quantity
4835
2
20
20
4
40
4
32
32
4
4
4
8
4
4
4
4
8
4
4
1
1
1
3
2
1
1
1
3
2
4
2
2
2
2
4
1
1
1
3
2
1
1
1
3
2
4
4
4
4
4
4
4
4
907807/HP1002
SL46/4835 SKID LOADERS - ENGINE
14
10
1
15
16
22
7
2
6
9
21
12
11
9 11
4
18
20
22
17
13
8
9
7
19
9
3
134069x1.cpt
907807/HP1002
5
PRINTED IN USA
SL46/4835 SKID LOADERS - ENGINE
Ref.
No.
Part
No.
Quantity
4635/SX
Description
1
134748
ENGINE/DEUTZ F3M1011F
134749
ENGINE/DEUTZ BF3M1011F
2
139181
BRACKET/MOUNT RIGHT
651378
SCREW/CAP HEX HEAD M14 X 35MM (108 ft-lbs) (Loctite® 242)
134966
WASHER/FLAT 1/2 (Loctite® 242)
3
135407
BRACKET/MOUNT LEFT
651378
SCREW/CAP HEX HEAD M14 X 35MM (108 ft-lbs) (Loctite® 242)
134966
WASHER/FLAT 1/2
4
136063
COUPLING/FLYWHEEL
656098
SCREW/CAP M8 X 20MM (Loctite® 242) (14 ft-lbs)
6
136056
HOUSING/FLYWHEEL
656141
SCREW/CAP SOCKET HEAD M10 X 25MM (28 ft-lbs)
7
135425
ASSEMBLY/MOUNT
651379
136601
NUT/HEX 5/8
8
078919
HOSE/FUEL
9
062023
CLAMP/HOSE #M5 (Do not Overtighten)
10
136107
FAN/17" BREEZA 10 BLADE (14 ft-lbs)
11
133074
FITTING/PIPE 1/4 (Pipe Thread Sealant)
12
076147
CLAMP/HOSE (Do Not Overtighten)
656093
SCREW/CAP HEX HEAD M8 X 16MM
656110
WASHER/LOCK
13
097076
HOSE/FUEL
14
138859b
STARTER
133557a
STARTER/2.3 kW
15
132300
ALTERNATOR/ 14 V - 55 AMP
16
132989
BELT/ALTERNATOR 10MM X 1050MM
17
132023
FILTER/ENGINE OIL
18
132024
FILTER/FUEL
19
135234
BRACKET/FILTER
656093
SCREW/CAP HEX HEAD M8 X 16MM (14 ft-lbs)
656110
WASHER/LOCK M8
650568
SCREW/CAP HEX HEAD 5/16 X 2 (13 ft-lbs)
131842
20
082339
LOOM/FLEX GUARD 18” (Cut length to fit on replacement)
21
074091
TIE/NYLON
22
135427
WASHER/SNUBBER
a) Engine serial numbers ~ 618097
b) Engine serial numbers 618098 ~
Quantity
46/4835SXT/DXT
1
1
3
3
1
2
2
1
6
1
9
2
2
2
1
6
1
2
1
1
1
1
1
1
1
1
1
1
1
2
2
2
2
1
1
2
1
1
3
3
1
2
2
1
6
1
9
2
2
2
1
6
1
2
1
1
1
1
1
1
1
1
1
1
1
2
2
2
2
1
1
2
ENGINE IDLE AND HIGH IDLE RPM CHART
TYPE OF ENGINE
IDLE (RPM)
HIGH IDLE (RPM)
F3M1011F
1300 ± 100
2800 ± 50
BF3M1011F
1300 ± 100
2690 ± 50
PRINTED IN USA
6
907807/HP1002
SL46/4835 SKID LOADERS - AIR CLEANER & MUFFLER
6
5
2
4
8
7
19
10
12
3
1
25
12
28
26
22
21
12
23
27
24
18
9 14
29
20
30
17
18
134071x1.cpt
907807/HP1002
7
PRINTED IN USA
SL46/4835 SKID LOADERS - AIR CLEANER & MUFFLER
Ref.
No.
1
2
3
4
5
6
7
8
9
10
12
14
17
18
19
20
21
22
23
24
25
26
27
28
29
30
Part
No.
134491
134685
134822
135086
078931
127428
131951
134691
135087
078912
131706
131842
131709
132072
135132
135167
135131
087849
078914
134642
088937
135157
650486
131842
135262
135259
095955
061166
135377
135372
135384
135261
135263
L99453
L99967
PRINTED IN USA
Quantity
4635/SX
Description
PIPE/FLEXIBLE EXHAUST
PIPE/FLEXIBLE EXHAUST
MUFFLER
MUFFLER
CLAMP/MUFFLER (Do Not Overtighten)
CLAMP/MUFFLER 2-1/2 (Do Not Overtighten)
CLAMP/MUFFLER 3” (Do Not Overtighten)
PIPE/EXHAUST
PIPE/EXHAUST
BAND/MOUNTING
ISOLATOR
BAR
BAR/MUFFLER SUPPORT
HOSE/INTAKE NA
HOSE/INTAKE TURBO
FILTER ASSEMBLY/AIR CLEANER
CLAMP/HOSE #52 (Do Not Overtighten)
GAUGE/RESTRICTION
PIPE/INTAKE
CLAMP/FILTER
HOSE/COUPLING 1/2
TUBE/INTAKE
CLAMP/HOSE #10
CLAMP/HOSE #36
SLEEVE/REDUCER
TUBE/AIR CLEANER
HOSE/AIR INTAKE
ASSEMBLY/COVER
EJECTOR/DUST
ELEMENT/AIR
FILTER/SAFETY
8
1
1
1
1
1
1
4
8
1
1
1
3
1
2
1
2
2
1
1
1
1
1
1
1
Quantity
46/4835SXT/DXT
1
1
1
1
1
1
4
8
1
1
1
3
1
1
2
1
2
2
1
1
2
1
1
1
1
1
1
1
1
907807/HP1002
SL46/4835 SKID LOADERS - OIL COOLER
16
11
10
16
5
1
12
15
3
14
9
13
5
2
8
5
17
17
17
3
6
7
4
17
To Engine Port - Fan End
To Engine Port - Flywheel End
134072x.cpt
907807/HP1002
9
PRINTED IN USA
SL46/4835 SKID LOADERS - OIL COOLER
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
Part
No.
131059
131863
076588
135108
135119
076588
132270
132271
135993
650453
134966
134853
055005
137018
134709
132035
132038
131842
135025
132036
132039
131842
132037
132040
131842
134710
135182
135183
072587
135383
127556
122348
135385
PRINTED IN USA
Quantity
4635/SX
Description
COOLER/STACKED
COOLER/STACKED
SCREW/FLANGE 3/8 X 3/4
ASSEMBLY/SHROUD
ASSEMBLY/SHROUD
SCREW/FLANGE 3/8 X 3/4
SEAL/SHROUD
SEAL/SHROUD
SUPPORT/SHROUD
WASHER/HEAT TREATED
FITTING/90° SAE12 X JIC12
HOSE/MEDIUM PRESSURE 3/4 X 21
SHROUD/LEFT
SHROUD/LEFT
SHROUD/RIGHT
SHROUD/RIGHT
SHROUD/CENTER
SHROUD/CENTER
PAD/COOLER
PAD/COOLER
FITTING/STRAIGHT SAE12 X JIC12
SEAL/SHROUD 19”
SEAL/SHROUD 22”
SEAL/SHROUD 16-5/8”
SEAL/SHROUD 1”
1
4
1
6
2
2
4
4
4
4
1
1
1
3
1
1
3
1
2
1
1
1
1
2
4
10
Quantity
46/4835SXT/DXT
1
4
1
6
2
2
4
4
4
4
1
1
1
3
1
1
3
1
2
1
1
1
1
2
4
907807/HP1002
SL46/4835 SKID LOADERS - HYDROSTATIC
22
38
28
6
7
14
6
18
1
21
2
34
4
2
4
40
26
2
35
3
39
19
29
14
23
8
20
9
14
17 9
14 5
10
13
16
24
9
14
15
12
11
24
36
25
32
37
41
14
5
9
27
33
134073x.cpt
907807/HP1002
11
PRINTED IN USA
SL46/4835 SKID LOADERS - HYDROSTATIC
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
32
33
34
35
36
37
38
39
40
41
a)
Part
No.
Quantity
4635
Description
Quantity
4835
136387a
PUMP/TANDEM 2.48 SERVO
1
650453
SCREW/CAP HEX HEAD 1/2 X 1-1/2 (Loctite® 242) (55 ft-lbs)
2
134966
WASHER/FLAT
2
135113
HOSE/VERY HIGH PRESSURE 5/8 X 25-1/2
3
135114
HOSE/VERY HIGH PRESSURE 5/8 X 26-1/2
1
131493b
FITTING/STRAIGHT SAE12 X FF10
4
131492b
FITTING/STRAIGHT SAE10 X FF10
4
054816
2
122641
TUBE/CHARGE
1
135017
1
068938
4
129063a
VALVE/SOLENOID
1
650706
2
071401
2
135432
WASHER/STAR 1/4
1
087393
FITTING/TEE
1
134649
TUBE/BRAKE
1
054994
1
054626
6
135272
TUBE/MOTOR DRAIN RIGHT
1
134645
TUBE/MOTOR DRAIN LEFT
1
129301
ORIFICE 5/8 DIAMETER
1
136293
1
131571
MANIFOLD
1
067847
1
654006
WASHER/FLAT 3/8
1
076879
CAP/37° FLARE 3/4
1
121684
1
131683
1
135451
ASSEMBLY/SUPPORT
1
650495
4
656188
SCREW/CAP HEX HEAD M10 (Loctite® 242) (28 ft-lbs)
2
134853
2
136467
ASSEMBLY/MOUNT
2
651379
1
136601
NUT/HEX 5/8
1
135436
MOUNT ASSEMBLY/PUMP
1
135440
MOUNT ASSEMBLY/PUMP
650495
3
134853
3
135448
SUPPORT/PUMP
1
650453
2
134966
WASHER/FLAT HEAT TREATED
2
135284
1
132053
1
132049
TEMPERATURE SWITCH
1
134647
TUBE/BRAKE RIGHT
1
134648
TUBE/BRAKE LEFT
1
076880
1
135387
SPACER/MANIFOLD
1
136101
TUBE/INNER MOUNT
1
135427
WASHER/SNUBBER
1
088046
1
080556
CAP/37° FLARE 9/16
1
128007
CLAMP/TUBE
1
135773
WASHER/FLAT 5/8
1
For breakdown see “Section B” of this manual. b) For #10 Face Seal O-Ring, order part number 135124.
PRESSURE SETTINGS
CHARGE PRESSURE
TANDEM RELIEF
PRINTED IN USA
1
2
2
3
1
4
4
2
1
1
4
1
2
2
1
1
1
1
6
1
1
1
1
1
1
1
1
1
1
1
4
2
2
2
1
1
1
3
3
1
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
AMOUNT OF PRESSURE
250-300 PSI @ Full Throttle (17-21 bar)
5500 PSI (379 bar)
12
907807/HP1002
SL46/4835 SKID LOADERS - HYDRAULICS - CHASSIS
4635 Model
1
29
8
12
20
9
18
1
41
10
22
12
9
4
9
27
4
17
11
26
28
30
38
9
39
25
6
37
4
19 40
4
11
5
2
9
35
13
4
15
11
16
9
24
34
9
31
4
14
12
36
10
12
9
7
18
32
134074x.cpt
907807/HP1002
13
PRINTED IN USA
Ref.
No.
Part
No.
Quantity
4635
Description
1
2
4
5
6
7
8
9
055005
061574
O-RING
067761
072580
075236
CAP/37° 7/8
079029
079092
FITTING/TEE SAE12 X JIC12 X JIC12
079098
PLATE/TWIN COVER
650568
SCREW/CAP HEX HEAD 5/16 X 2 (Do Not Overtighten)
064260
NUT/LOCK NYLON INSERT 5/16 (Do Not Overtighten)
10
079126
CLAMP/TUBE 5/8 (PAIR)
11
088904
CLAMP/TUBE 1/2
12
135331
STRAP
13
135139
14
114415
HOSE/SUCTION 1 X 80
15
122340
FITTING/TEE JIC08 X SAE08 X JIC08
16
122899
FITTING/STRAIGHT SAE10 X SAF08
17
127349
18
129314a
VALVE/SOLENOID
650449
134588
135432
WASHER/STAR 1/4
19
131577
PLUG SAE10
20
131838
FILTER ASSEMBLY/HYDRAULIC
651041
22
134535
TUBE/TILT
24
134613
TUBE/TILT
25
134614
TUBE/TILT
26
134615
TUBE/TILT SOLENOID
27
134616
TUBE/TILT
28
135297
TUBE/RETURN
29
137018
30
134793
TUBE/LIFT FRONT
31
134794
TUBE/LIFT REAR
32
134830
TUBE/LIFT
34
134878a
PUMP/GEAR 1.77
650491
SCREW/CAP HEX HEAD 3/8 X 1-1/4 (Loctite® 242)
35
134923
TUBE/LIFT
36
134980
BRACE
37
135032
38
122778
PLUG 9/16
39
089001
CLAMP
650490
134852
40
072587
STRAIGHT/FITTING SAE12 X JIC12
41
074830
FILTER/HYDRAULIC
PRESSURE SETTINGS
CONTROL VALVE RELIEF
PRINTED IN USA
2
1
6
2
2
1
1
8
5
5
2
3
4
1
1
1
1
1
2
4
4
2
2
1
4
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
AMOUNT OF PRESSURE
2750±50 PSI @ Full Throttle (190±4 bar)
14
907807/HP1002
SX & SXT Models
7
31
19
1
11
18
27
9
11 8
16
8
10
4
43
22
28
32
4
42
26
15
8
11
8
10
24
36
8
12
8
9
5
5
13
29
8
9
9
6
18
8
41
4
11
4
10
4
44
2
14
33
25
40
1
45
8
37
35
38
4
34
17
9
8
30
4
134075x.cpt
907807/HP1002
15
PRINTED IN USA
Ref.
No.
1
2
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
22
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
40
41
42
43
44
45
a)
Part
No.
Quantity
46/4835SX/SXT
Description
055005
061574
O-RING
067761
072580
079029
079092
079098
PLATE/TWIN COVER
650568
650833
064260
079126
CLAMP/TUBE 5/8
088904
CLAMP/TUBE 1/2
135331
STRAP
135139
114415
HOSE/SUCTION 1 X 80
122340
122899
127349
135367a
VALVE/SELF LEVEL
650733
131842
129314a
VALVE/SOLENOID
650449
134588
135432
WASHER/STAR 1/4
131838
651041
134535
TUBE/TILT
134613
TUBE/TILT
134614
TUBE/TILT
134615
TUBE/TILT SOLENOID
134616
TUBE/TILT
135297
TUBE/RETURN
134621
TUBE/AUXILIARY FRONT
134622
TUBE/AUXILIARY REAR
137018
134793
TUBE/LIFT FRONT
134794
TUBE/LIFT REAR
134830
TUBE/LIFT
134831
TUBE/LIFT
134832
TUBE/TILT
134833
TUBE/TILT
134834
TUBE/TILT REAR
134878a
PUMP/GEAR 1.77
650491
135032
122778
PLUG 9/16
089001
CLAMP
650490
134852
072587
STRAIGHT/FITTING SAE12 X JIC12
074830
FILTER/HYDRAULIC
For breakdown see “Section B” of this manual.
2
1
10
4
1
1
12
4
2
6
5
3
4
1
1
1
1
1
1
2
2
2
4
4
2
1
4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
PRESSURE SETTINGS
AMOUNT OF PRESSURE
PRINTED IN USA
16
907807/HP1002
DXT Model
7
DX Indicator Lamp
(Found on Instrument Panel)
21
38
67
7
70
36
39
52
18
12
63
51
8
26
24
12
50
5
31
8
11
30
40
8
5
29
72
66
8
41
37
73
34
8
11
28
8
11
5
8
32
5
135027x1.cpt
2
8
9
6
53
9
35
10
8
11
47
33
42
15
12
12
18
8
17
8
5
907807/HP1002
44
5
43
13
46
5
45
8
71
6
14
9
27
5
19
74 16
68
9
65
5(46)
3(48)
71
71
69
20
1
71
49
64
17
5
PRINTED IN USA
Ref.
No.
1
2
3
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
24
26
27
28
29
30
31
32
33
a)
Part
No.
Quantity
4635DXT
Description
055005
061574
O-RING
062397
067761
072580
079092
079098
PLATE/TWIN COVER
650568
650833
064260
079126
CLAMP/TUBE 5/8
079288
088904
CLAMP/TUBE 1/2
135331
STRAP
135139
122340
122899
127349
135367a
VALVE/SELF LEVEL
650733
131842
129314a
VALVE/SOLENOID
650449
134588
135432
WASHER/STAR 1/4
129706a
PUMP/GEAR DOUBLE 1.77/1.02
650491
135032
131838
651041
134535
TUBE/TILT
134599a
VALVE/DX
650577
131842
134613
TUBE/TILT
134614
TUBE/TILT
134615
TUBE/TILT SOLENOID
134616
TUBE/TILT
135297
TUBE/RETURN
134621
TUBE/AUXILIARY FRONT
134622
TUBE/AUXILIARY REAR
1
1
11
4
2
12
4
2
6
5
1
3
4
1
1
1
1
1
2
2
2
4
4
2
1
2
1
1
4
1
1
2
2
1
1
1
1
1
1
1
Quantity
4835DXT
1
1
1
10
4
2
12
4
2
6
5
1
3
4
1
1
1
1
1
2
2
2
4
4
2
1
2
1
1
4
1
1
2
2
1
1
1
1
1
1
1
Parts List Continued on Next Page
PRESSURE SETTINGS
HIGH FLOW RELIEF
PRINTED IN USA
AMOUNT OF PRESSURE
18
907807/HP1002
DXT Model
7
DX Indicator Lamp
(Found on Instrument Panel)
21
38
67
7
70
36
39
52
18
12
63
51
8
26
24
12
50
5
31
8
11
30
40
8
5
29
72
66
8
41
37
73
34
8
11
28
8
11
5
8
32
5
135027x1.cpt
2
8
9
6
53
9
35
10
8
11
47
33
42
15
12
12
18
8
17
8
5
907807/HP1002
44
5
43
13
46
5
45
8
71
6
14
9
27
5
19
74 16
68
9
65
5(46)
3(48)
71
71
69
20
1
71
49
64
19
5
PRINTED IN USA
Ref.
No.
Part
No.
Description
(continued from previous page)
34
134643
BRACKET/DX VALVE
650487
131842
35
134724
36
134774
TUBE/DX OUTLET
37
134775
TUBE/DX INLET
38
134776
TUBE/DX
39
134777
TUBE/DX
40
134793
TUBE/LIFT FRONT
41
134794
TUBE/LIFT REAR
42
134830
TUBE/LIFT
43
134831
TUBE/LIFT
44
134832
TUBE/TILT
45
134833
TUBE/TILT
46
134834
TUBE/TILT REAR
47
134837
HOSE/SUCTION 1-1/4 x 80
49
134879
CLEVIS/M10
50
134988
BOX/LEVER PIVOT
650733
131842
51
135007
SPACER
52
135009
ROD/CONTROL
135030
ROD/CONTROL
53
135018
FITTING/TEE SAE10 x JIC12
63
656048
NUT/HEX M8
64
656049
NUT/HEX M10
65
134880
CLEVIS/M8
66
132213
PLUG/POWER BEYOND
67
137018
68
135031
SWITCH/MICRO
69
134991
LEVER/HAND
70
135179
LAMP ASSEMBLY/INDICATOR
71
072587
72
122778
PLUG 91/6
73
089001
CLAMP
650490
134852
74
074830
FILTER/HYDRAULIC
PRESSURE SETTINGS
HIGH FLOW RELIEF
PRINTED IN USA
Quantity
4635DXT
Quantity
4835DXT
1
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
1
5
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
1
5
1
1
1
1
1
AMOUNT OF PRESSURE
20
907807/HP1002
Main Control Valve - T-Bar and Dual Hand
Mcv-tbdh.cpt
907807/HP1002
21
PRINTED IN USA
Ref.
No.
Part
No.
Description
1
2
3
650490
SCREW/CAP 3/8 X 1
134852
132210a
VALVE/3-SPOOL
132692a
VALVE/3-SPOOL
PRINTED IN USA
22
Quantity
T-Bar
Quantity
Dual Hand
4
4
1
-
4
4
1
907807/HP1002
Main Control Valve - Hand and Foot
136236x.cpt
907807/HP1002
23
PRINTED IN USA
Ref.
No.
Part
No.
Quantity
46/4835
Description
1
650568
SCREW/CAP 5/16 X 2
2
650490
SCREW/CAP 3/8 X 1
3
650486
4
136151
5
136150
6
136149
7
136148
8
136143
ASSEMBLY/BRACKET
9
137291
VALVE/PILOT CONTROL
10
136072
PLATE/ORIFICE
11
136054a
VALVE/CONTROL
12
134852
13
131842
14
122340
15
074091
TIE/NYLON
16
068938
17
054994
a) For breakdown see “Section B” in this manual.
PRINTED IN USA
2
4
2
1
1
1
1
1
1
1
1
4
2
1
1
1
5
24
907807/HP1002
SL46/4835 SKID LOADERS - HYDRAULICS - LIFT ARM
4635
32
34
37
27
5
25
26
38
7
11
10
13
36
14
27
14
17
13
16
5
38
11
15
13
12
7
13
10
17
38
7
22
7
24
23
23
22
18
12
38
19
21
18
24
134077x.cpt
907807/HP1002
25
PRINTED IN USA
Ref.
No.
5
7
10
11
12
13
14
15
16
17
18
19
21
22
23
24
25
26
27
32
34
36
37
38
a)
Part
No.
Quantity
4635
Description
079126
CLAMP/TUBE 5/8 (PAIR)
079098
PLATE/TWIN COVER
650545
SCREW/CAP HEX HEAD 5/16 X 1-1/4 (Do Not Overtighten)
650547
134368a
CYLINDER/LIFT
134523
PIN/LIFT CYLINDER (Lithium Grease)
650818
067847
134522
650535
067847
054626
TEE/STRAIGHT SAE08 X JIC08
134511
TUBE/LIFT CYLINDER
134513
TUBE/LIFT CYLINDER LEFT
134512
TUBE/LIFT CYLINDER RIGHT
087849
135058a
CYLINDER/TILT 2-1/2 X 17.3
135306
PIN/TILT CYLINDER (Grease on taper of pin) (80 ft-lbs)
651366
134966
WASHER/FLAT
131689
TUBE/TILT
088904
CLAMP/TUBE 1/2
134855
HOSE/MEDIUM PRESSURE 3/8 X 13, W/ PROTECTIVE SLEEVE
134856
134456
TUBE/TILT INNER
134455
TUBE/TILT OUTER
132062
SPACER/TILT TUBE
134702
134697
134696
131529
PLUG SAE08
570002
FITTING/GREASE
PRINTED IN USA
26
2
4
2
2
2
2
2
2
2
2
2
4
2
1
1
2
2
2
2
2
2
2
2
2
1
1
2
2
2
2
1
4
907807/HP1002
SX & SXT Models
32
27
5
38
7
26
11
33
10
13
25
5
14
16
5
14
1
38
12
17
7
22
22
10
7
46
29
23
24
8
19
18
11
7
15
13
38
7
36
13
17
27
31
34
37
5
7
9
2
13
38
23
12
21
30
18
24
134078x.cpt
907807/HP1002
27
PRINTED IN USA
Ref.
No.
1
2
5
7
8
9
10
11
12
13
14
15
16
17
18
19
21
22
23
24
25
26
27
29
30
31
32
33
34
36
37
38
Part
No.
134485
134483
079126
079098
650545
650568
650547
134464
134474
134368a
134523
650818
067847
134522
650535
067847
054626
134511
134513
134512
087849
135058a
135306
651366
134966
131689
088904
134855
134856
134456
134455
132062
131952
131953
134698
134702
074395
067847
654006
134697
134857
134696
134858
131529
570002
Description
TUBE/AUXILIARY INNER
TUBE/AUXILIARY OUTER
CLAMP/TUBE 5/8
PLATE/TWIN COVER
TUBE, W/TEE
TUBE, W/TEE
CYLINDER/LIFT
TEE/STRAIGHT SAE08 X JIC08
TUBE/LIFT CYLINDER
TUBE/LIFT CYLINDER LEFT
TUBE/LIFT CYLINDER RIGHT
CYLINDER/TILT 2-1/2 X17.3
WASHER/FLAT
TUBE/TILT
CLAMP/TUBE 1/2
HOSE/MEDIUM PRESSURE 3/8 X 13 W/ PROTECTIVE SLEEVE
HOSE/MEDIUM PRESSURE 3/8 X 18 W/ PROTECTIVE SLEEVE
TUBE/TILT INNER
TUBE/TILT OUTER
SPACER/TILT TUBE
COUPLER/MALE
COUPLER/FEMALE
WASHER/FLAT 3/8
PLUG SAE08
FITTING/GREASE
46
075236
CAP/37 FLARE 7/8
PRINTED IN USA
28
Quantity
4635SX
Quantity
46/4835SXT
1
1
4
6
2
2
2
1
1
2
2
2
2
2
2
2
4
2
1
1
2
2
2
2
2
2
2
2
2
1
1
2
1
1
2
2
1
1
1
2
2
1
4
1
1
4
6
2
2
2
1
1
2
2
2
2
2
2
2
4
2
1
1
2
2
2
2
2
2
2
2
2
1
1
2
1
1
2
2
1
1
1
2
2
1
4
2
2
907807/HP1002
DXT Model
43
37
13
32
40
31
34
4
6
5
3
42
38
41
11
45
10
26
14
25
16
6
13
17
1
38
11
38
2
12
41
42
13
17
10
7
22
24
23
13
7
15
5
28 27
36
5
14
13
39
33
7
5
46
22
8
9
29
12
7
38
23
19
21 30
18
18
24
134079x.cpt
907807/HP1002
29
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
21
22
23
24
25
26
27
28
29
30
31
32
33
34
36
37
38
39
40
41
42
43
Part
No.
134485
134483
134496
134497
079126
079097
079098
650545
650568
650547
134464
134474
134368a
134523
650818
067847
134522
650535
067847
054626
134511
134513
134512
087849
135058a
135306
651366
134966
131689
088904
134855
134856
134456
134455
131771
131772
131952
131953
134698
134702
074395
067847
654006
134697
134857
134696
134858
134728
570002
131958
134509
132148
650547
654024
076147
650758
070634
134729
Quantity
4635DXT
Description
TUBE/AUXILIARY INNER
TUBE/AUXILIARY OUTER
TUBE/HI-FLOW INNER
TUBE/HI-FLOW OUTER
CLAMP/TUBE 5/8
CLAMP/TUBE 3/4
PLATE/TWIN COVER
TUBE, W/TEE
TUBE, W/TEE
CYLINDER/LIFT
TUBE/LIFT CYLINDER
TUBE/LIFT LEFT CYLINDER
TUBE/LIFT RIGHT CYLINDER
CYLINDER/TILT 2-1/2 X17.3
WASHER/FLAT
TUBE/TILT
CLAMP/TUBE 1/2
HOSE/MEDIUM PRESSURE 3/ 8 X 18, W/ PROTECTIVE SLEEVE
TUBE/TILT INNER
TUBE/TILT OUTER
COUPLER/MALE
COUPLER/FEMALE
COUPLER/MALE
COUPLER/FEMALE
WASHER/FLAT 3/8
FITTING/GREASE
COUPLER/MALE FLAT FACE
TUBE/HI-FLOW DRAIN
BAR (Do Not Overtighten)
WASHER/LOCK 5/16
NUT/SERRATED LOCK, W/FLANGE 1/4
46
075236
CAP/37 7/8
PRINTED IN USA
30
Quantity
4835DXT
1
1
1
1
4
2
6
2
2
2
1
1
2
2
2
2
2
2
2
4
2
1
1
2
2
2
2
2
2
2
2
2
1
1
1
1
1
1
2
2
1
1
1
2
2
2
4
1
1
2
2
2
2
2
2
1
1
1
1
1
4
2
6
2
2
2
1
1
2
2
2
2
2
2
2
5
2
1
1
2
2
2
2
2
2
2
2
2
1
1
1
1
1
1
2
2
1
1
1
2
2
2
4
1
1
2
2
2
2
2
2
1
2
2
907807/HP1002
SL46/4835 SKID LOADERS - AUXILIARY HYDRAULIC CONTROLS
T-Bar and Dual Hand Models
7
9
12
11
8
5
6
10
3
1
4
6
2
11
7
134081x2.cpt
907807/HP1002
31
PRINTED IN USA
Ref.
No.
Part
No.
Quantity
T-Bar/Dual Hand
Description
1
135310a
SUPPORT ASSEMBLY/PEDAL
650487
064260
654004
WASHER/FLAT 5/16
2
135309b
ASSEMBLY/AUXILIARY PEDAL
067847
654006
WASHER/FLAT 3/8
3
135312c
BAR/STOP
4
127360
BUSHING/PIVOT
650692
B11296
WASHER/FLAT 11/32
064260
5
115039
CABLE/CONTROL
6
079614
CLAMP/CONDUIT
121002
7
065164
END/YOKE
650648
NUT/HEX #10
8
127488
PIN/CLEVIS 3/16 X 5/8
650551
PIN/COTTER 3/32 X 3/4
9
088254
LEVER/AUXILIARY VALVE
10
087974
JOURNAL/PIVOT
11
079213
PIN/SPRING CLEVIS 3/16
12
134760
BRACKET/CABLE
650486
131842
a) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132165.
Serial number 9514 and later on SL4835 models. Earlier serial number models use part number 132165.
b) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132175.
c) Serial number 27508 and later on SL4635 models. Earlier serial number models use part number 132209.
PRINTED IN USA
32
1
3
3
3
1
1
1
1
1
1
1
1
1
2
4
2
2
2
2
1
1
2
1
2
2
907807/HP1002
Hand and Foot Models - Electric Auxiliary Control
13
12
2
1
3
10
6
5
8
7
4
11
9
134082x2.cpt
907807/HP1002
33
PRINTED IN USA
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
Part
No.
132104
131093
650485
654002
074868
127717
074868
136351
135125
127623
650551
127488
650551
132075
650542
134588
058615
132149
650702
132069
132073
131088
PRINTED IN USA
Electric Aux.
Hand/Foot Qty.
Description
ACTUATOR/LINEAR
KIT/MOUNT
WASHER/FLAT 1/4
SPACER
CLEVIS/ASSEMBLY
SPACER
BRACKET ASSEMBLY/PIVOT
LEVER
PIN/CLEVIS 3/16
PIN/CLEVIS 3/16
ERC ASSEMBLY/ELECTRICAL AUXILIARY
CLAMP/INSULATED
HOUSING/SWITCH
SCREW/SELF-TAPPING PAN HEAD PHILLIPS #6 X 3/8
HARNESS/MAIN ELECTRICAL AUXILIARY
HARNESS/PANEL ELECTRICAL AUXILIARY
SWITCH/ROCKER
34
1
1
1
1
1
1
2
1
1
1
1
1
1
1
4
4
2
1
1
1
1
1
907807/HP1002
Hand and Foot Models - Mechanical Auxiliary Control
136252x.cpt
907807/HP1002
35
PRINTED IN USA
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Part
No.
071401
132346
132370
132372
132373
132387
134588
135318
135996
136003
136008
136011
650225
650484
650542
650580
650835
650839
PRINTED IN USA
Mechanical Aux.
Hand/Foot Qty.
Description
NUT/HEX 1/4
SPACER/PIVOT
CABLE/54”
ROD END/FEMALE 1/4
BEARING/FLANGED 1/2
KIT/VALVE
GRIP/RUBBER
ASSEMBLY/GRIP
HANDLE/LOWER
ASSEMBLY/GRIP
HANDLE/LOWER
SCREW/SET 5/16 X 1/2
SCREW/CAP 1/4 X 1/2
WASHER/FLAT 3/16
SCREW/CAP 1/4 X 1
SCREW/CAP 1/4 X 2-1/4
2
1
1
1
2
1
4
2
1
1
1
1
2
2
4
2
1
1
36
907807/HP1002
SL46/4835 SKID LOADERS - CONTROLS - LIFT TILT
T-Bar Model
1
16
14
15
7
6
5
12
15
6
2
3
9
7
4
13
3
11
2
10
11
134083x3.cpt
907807/HP1002
37
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
9
10
11
12
13
14
15
16
Part
No.
134889
128316
056937
134327
054202
653039
134792
650634
650533
654004
134852
079039
650491
074868
135393
135081
134865
653039
135082
134866
653039
127488
650551
074093
PRINTED IN USA
Description
HANDLE ASSEMBLY/CONTROL
BEARING/BRONZE
WASHER/FLAT 25/32
STOP/T-BAR
JOINT/BALL
NUT/JAM HEX 3/8 (Loctite® 242)
ROD END/ELASTOMERIC 3/8
SCREW/CAP HEX HEAD 3/8 X1
WASHER/FLAT 5/16
ROD/END FEMALE
SPACER
PIVOT
ROD/LIFT CONTROL
ROD/LIFT CONTROL
NUT/JAM HEX 3/8
ROD/TILT CONTROL
ROD/TILT CONTROL
NUT/JAM HEX 3/8
PIN/CLEVIS 3/16
BOOT/CONTROL LEVER
38
Quantity
4635 T-Bar
Quantity
4835 T-Bar
1
2
2
1
1
1
2
2
2
2
2
1
1
2
1
1
1
1
1
2
2
1
1
2
2
1
1
1
2
2
2
2
2
1
1
1
1
1
1
1
1
2
2
1
907807/HP1002
Hand and Foot Model
136255x.cpt
907807/HP1002
39
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
Part
No.
653039
651523
651573
650551
650491
136253
136251
136190
136138
136134
135145
135158
135140
135137
134852
134241
132393
131842
128316
127488
123383
088912
079039
075288
072866
056937
PRINTED IN USA
Quantity
4635 Hand/Foot
Description
NUT/JAM 3/8
NUT/JAM M12
BOLT/CARRIAGE 5/16 X 1
PIN/COTTER
ROD/THROTTLE
CLIP/RETAINING
TAB/THREADED M12 X 1-1/4
PEDAL ASSEMBLY/LEFT
PEDAL ASSEMBLY/RIGHT
CONTROL ROD/LIFT
CONTROL ROD/LIFT
ASSEMBLY/LEVER
ASSEMBLY/PIVOT
SPACER/PIVOT
BRACKET/BEARING
BUSHING/PIVOT
PIN/CLEVIS
ROD END 3/8
WASHER/FLAT
ROD END
PIN/ROLL 5/16 X 1-1/4
STUD
WASHER/FLAT 25/32
2
1
4
1
4
1
2
1
1
1
1
1
1
5
1
2
4
6
1
1
1
3
1
1
3
40
Quantity
4835 Hand/Foot
2
1
4
1
4
1
2
1
1
1
1
1
1
5
1
2
4
6
1
1
1
3
1
1
3
907807/HP1002
Dual Hand Model
131315x.cpt
907807/HP1002
41
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Part
No.
071401
132346
132370
132371
132372
132373
132387
135318
132321
132320
650225
650484
650580
650835
PRINTED IN USA
Quantity
Dual Hand
Description
NUT/LOCK 1/4
PIVOT/SPACER
CABLE 54
CABLE 72
ROD END/FEMALE 1/4
BEARING/FLANGED
KIT/CABLE MOUNT
GRIP/RUBBER
ASSEMBLY/GRIP
HANDLE/LOWER
SCREW/SET SQUARE HEAD 5/16 X 1/2
WASHER/FLAT 3/16
SCREW/CAP 1/4 X 1
2
2
1
1
2
4
2
2
2
2
2
4
4
2
42
907807/HP1002
SL46/4835 SKID LOADERS - CONTROLS - TRACTION
T-Bar Model
8
7
13
8
18
10
15
6
9
10
17
18
12
19
14
10
10
1
20
11
8
21
6
7
14
4
12
7
8
19
10
3
8
7
2
9
4
10
7
16
8
10
6
5
134086x2.cpt
907807/HP1002
43
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
Part
No.
134888
134327
650533
134852
135393
134792
650533
134852
650634
134532
075288
056937
128316
134400
650687
131842
079216
134851
127669
134658
134659
134757
656048
654002
123722
653036
134436
653036
134437
653036
134983
650492
134852
650491
134852
650453
134853
074093
PRINTED IN USA
Quantity
T-Bar
Description
HANDLE ASSEMBLY/CONTROL
STOP/T-BAR
PIVOT
ASSEMBLY/PIVOT
PIN/ROLL 5/16 X 1-1/4
WASHER/FLAT 25/32
BEARING/BRONZE
BAR/BEARING PIVOT
ROD END/FEMALE W/ STUD
SHAFT/PIVOT
ASSEMBLY/LEVER
TUBE ASSEMBLY/PIVOT
DEVICE/CENTERING
NUT/HEX M8
WASHER/FLAT 1/4
ROD/TAKEUP
NUT/JAM HEX 5/16 (Loctite® 242)
ROD/9-1/4
NUT/JAM HEX 5/16
ROD/4-3/4
NUT/JAM HEX 5/16
ARM ASSEMBLY/CONTROL
BOOT/CONTROL LEVER
1
1
1
1
1
2
2
2
2
1
3
AR
6
2
4
4
8
8
1
2
1
2
4
2
1
2
2
4
1
2
2
2
2
1
2
2
2
1
44
907807/HP1002
Hand and Foot Model
36
31
5
3
11
9
20
8
1
20
9
8
3
26
21
6
14
20
20
5
20
31
31
26
13
33
33
35
5
10
15
31
5
30
21
23
23
20
31
16
5 31
5
18
7
21
29
2
24
10
25
1
32
17
27
31
17
21
19
29
32 27
11
12
14
1
33
2 25
9
32
17
8
16
29
31
8
35
33
12
31
20
22
3
21
31
29
5
32
21
30
27
17
20
134087x2.cpt
907807/HP1002
45
PRINTED IN USA
Ref.
No.
1
2
3
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
29
30
31
32
33
35
36
Part
No.
056937
074093
075288
079216
123722
135605
128316
131842
135318
134400
134436
134437
134658
134659
135332
134792
135604
134814
134851
134852
134853
134983
650453
650491
650492
650533
650634
650687
653036
654004
656048
654002
135607
PRINTED IN USA
Quantity
Hand/Foot
Description
WASHER/FLAT 25/32
BOOT/CONTROL LEFT
PIN/ROLL 5/16 X 1-1/4
END/ROD FEMALE
ROD/TAKEUP
SHAFT/PIVOT
BEARING/SINTERED BRONZE
GRIP/RUBBER (Silicone Lubricant)
BAR/BEARING PIVOT
ROD 9-1/4
ROD 4-3/4
ASSEMBLY/LEVER
TUBE ASSEMBLY/PIVOT
DEVICE/CENTERING
END/ROD ELASTOMERIC
LEVER/CONTROL RIGHT
LEVER/CONTROL LEFT
NUT/JAM HEX 5/16
WASHER/FLAT 5/16
NUT/HEX M8 X 1-1/4
WASHER/FLAT 1/4
ARM/ASSEMBLY
4
2
3
8
1
1
4
4
2
2
2
1
2
1
2
4
1
1
8
10
2
2
2
2
2
4
4
4
8
4
4
2
1
46
907807/HP1002
Dual Hand Model
6
22
3
8
9
8
3
11
16
15
6
6
7
10
14
16
6
6
13
6
12
2
18
8
17
9
3
5
21
4
4
4
8
2
13
17
4
10
9
21
7
6
134088x2.cpt
907807/HP1002
47
PRINTED IN USA
Ref.
No.
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
21
22
Part
No.
135069
075288
134792
650634
650533
134852
654004
134436
079216
653036
134851
134400
650573
131842
128316
056937
134658
134659
135605
135332
656048
654002
134437
123722
134983
650492
134852
074093
650453
134853
650490
134852
135607
PRINTED IN USA
Quantity
Dual Hand
Description
ASSEMBLY/LEVER
PIN/ROLL 5/16 X 1-1/4
WASHER/FLAT 5/16
ROD/9-1/4
ROD END/FEMALE W/ STUD 5/16
NUT/JAM HEX 5/16
BAR/BEARING PIVOT
BEARING/BRONZE
WASHER/FLAT 25/32
ASSEMBLY/LEVER
TUBE ASSEMBLY/PIVOT
SHAFT/PIVOT
DEVICE/CENTERING
NUT/HEX M8
WASHER/FLAT 1/4
ROD/4-3/4
ROD/TAKEUP
BOOT/CONTROL LEVER
ARM/ASSEMBLY
2
3
4
4
4
4
4
2
8
8
8
2
4
4
4
4
2
1
1
2
4
2
1
1
2
2
2
2
2
2
2
4
1
48
907807/HP1002
SL46/4835 SKID LOADERS - CONTROLS - ENGINE
T-Bar and Dual Hand Models
17
18
1
11
2
14
8
13
9
3
8
12
9
6
15
16
4
10
6
7
5
19
134089x2.cpt
907807/HP1002
49
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
Part
No.
134914
650491
067847
136475
136251
139108
650551
650552
654004
134243
134241
128316
088912
067847
131262
065164
650648
079213
127488
655001
065163
650387
650648
650549
131110
656149
654002
134398
650490
134852
134447
135772
062282
124078
072866
PRINTED IN USA
Quantity
T-Bar/Dual Hand
Description
LEVER ASSEMBLY/THROTTLE
ROD/CONTROL
CLIP/RETAINING
CLEVIS/HALF 3/8
NUT/HEX 3/8
WASHER/FLAT 5/16
PEDAL ASSEMBLY/FOOT
SPACER/PIVOT
BEARING/BRONZE
WASHER
CABLE/THROTTLE
END/YOKE
NUT/HEX #10
PIN/SPRING CLEVIS 3/16
PIN/CLEVIS 3/16
CLAMP
SCREW/MACHINE ROUND HEAD #10 X 1/2
NUT/HEX #10
WASHER/LOCK #10
LEVER/THROTTLE
SCREW/CAP HEX HEAD M6 X 16MM (8 ft-lbs)
WASHER/FLAT 1/4
BRACKET/CABLE SUPPORT
BRACKET/SPRING
SPRING
GRIP
WASHER
STUD
50
1
1
1
1
2
1
1
1
1
1
1
2
1
1
1
2
2
1
1
1
1
2
2
2
1
2
2
1
1
1
1
1
1
3
1
907807/HP1002
Hand and Foot Model
9
1
10
2
7
8
3
5
4
11
6
134090x2.plt
907807/HP1002
51
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
Part
No.
136239
650491
067847
114449
650648
650549
135171
650494
134853
065164
650648
127488
655001
065163
650387
650549
650648
131110
656149
654022
134398
650490
134852
062282
124078
131262
PRINTED IN USA
Quantity
Hand/Foot
Description
HANDLE ASSEMBLY/HAND & FOOT
ROD END/#10 WITH STUD
NUT/HEX MACHINE SCREW #10
WASHER/LOCK #10
BRACKET/CABLE
END/YOKE
PIN/CLEVIS 3/16
CLAMP
WASHER/LOCK #10
LEVER/THROTTLE
SCREW/CAP HEX HEAD M6 X 16 (8 ft-lbs)
WASHER/LOCK 1/4
BRACKET/CABLE
GRIP
WASHER
CABLE/THROTTLE
52
1
1
1
1
2
1
1
1
1
1
1
1
1
1
2
2
2
1
2
2
1
1
1
1
3
1
907807/HP1002
SL46/4835 SKID LOADERS - LIFT ARM & ATTACHMENT SYSTEM
2
11
2
4
1
11
8
12
6
7
54
53
64 60
11 10 13
52 57
55
51
59
54
52
50 60
5
3
53
9
56
51
57
13
10 11
59
64
134091x.gif
907807/HP1002
53
PRINTED IN USA
SL46/4835 SKID LOADERS - LIFT ARM & ATTACHMENT SYSTEM
Ref.
No.
Part
No.
Quantity
All-Tach™
Attachment
Description
1
2
3
4
133970
ARM/LIFT
1
134356
BUSHING (Loctite® 680)
4
088101
BUSHING/SPRING
2
134523
PIN/LIFT CYLINDER
2
650818
2
067847
2
570002
FITTING/GREASE
2
5
131176
ARM/SAFETY (Do Not Overtighten)
1
650483
1
079209
1
6
087854
PAD/ARM BRACE
1
7
074860
STEM/RUBBER
1
8
131785
PIN/QUICK RELEASE
1
132289
RIVET/BLIND
1
9
131443
SHIM
AR
650490
SCREW/CAP HEX HEAD 3/8 X 1 (Loctite® 242)
4
654026
WASHER/LOCK 3/8
4
10
132088
CAP/GREASE
2
650486
SCREW/CAP HEX HEAD 5/16 X 3/4 (Loctite® 242)
6
11
570002
FITTING/GREASE
2
12
131201
STEP
1
651168
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 3/8 X 3/4
6
13
134579
PIN (Grease)
2
651372
2
135773
WASHER/FLAT HEAT TREATED 5/8
2
50
137190
ATTACHMENT/ALL-TACH™ (Lithium Grease)
1
136765a
SHIM
AR
136766a
SHIM
AR
51
134219
PIN
2
52
134594
ROD/PUSH
2
651542
2
53
123554
SPRING/COMPRESSION
2
54
134874
ADAPTER/PUSH ROD
2
137214
WASHER/THRUST
2
651297
SCREW/CAP HEX HEAD 3/8 X 1 (Loctite® 242)
2
55
137212
HANDLE/RIGHT
1
56
137211
HANDLE/LEFT
1
57
134707
SPRING/COMPRESSION
2
654009
WASHER/THRUST 1/2
2
068034
2
59
651364
SCREW/CAP SOCKET HEAD 1/2 X 3-1/2
2
60
062756
PIN/SPRING
2
64
135300
PIN
2
650492
2
067847
2
a) Add shims 136765 and 136766 as required to achieve a gap between the liftarm and the All-Tach from 0.000” to 0.060” wide.
PRINTED IN USA
54
907807/HP1002
SL46/4835 SKID LOADERS - ROPS & SEAT
22
5
44
(Interior Top of ROPS)
(Interior - Right
Rear of ROPS)
43
6
18
4
20
1
11
10
14
12
2
13
3
2
38
14
15
2
17
9
21
15
37
16
8
7
135034x1.cpt
19
907807/HP1002
55
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
37
38
43
44
Part
No.
131060
650499
654012
067823
057557
064543
650850
068034
131766
131767
131768
121412
650495
654009
068034
130085
070648
L62459
650771
071401
131805
122828
650850
654009
655006
077794
135177
089010
070648
089012
135240
067750
651307
131945
131691
132179
064260
650394
650658
129420
132089
703692
134681
135252
058615
132288
076147
651168
PRINTED IN USA
Quantity
4635
Description
ROPS
SCREW/CAP HEX HEAD 5/8 x 5-1/2
WASHER/FLAT 5/8
WASHER/FLAT 17/32
MOUNTING/ISOLATION
WINDOW/ROPS
WEATHERSTRIP/WINDOW
RIP CORD/WEATHERSTRIP
BELT/SEAT
SCREW/CAP HEX HEAD 1/2 X1-1/4
WASHER/FLAT 1/2
SEAT
NUT/FLANGED LOCK
CASE/OPERATOR’S MANUAL
ASSEMBLY/LIMITER
SLEEVE
WASHER/FLAT 1/2
PIN/COTTER 1/8 X 1
SPRING/TORSION
SPRING/GAS
STUD/BALL
NUT/FLANGED LOCK
CLIP/SPRING
FILLER/ROPS
NUT/SPEED
SCREW/PHILLIPS ROUND HEAD 1/4 X 1/2
BUSHING
SLIDE/SEAT (SET)
BULKHEAD/HARNESS
NUT/HEX #6
PLUG/PLASTIC 3/4
WINDOW/ENCLOSURE
TAPE/TWO-WAY 6.25 FT. (ATTACH WINDOW TO TOP OF ROPS)
PLUG/PLASTIC 15/32
PLUG/PLASTIC 3/8
CLAMP/INSULATED
SCREW/CAP HEX WASHER HEAD THREADED 5/16 X 1
CLAMP/HOSE
SCREW/CAP HEX WASHER HEAD THREADED 3/8 X 3/4
56
1
2
2
2
6
2
2
2
1
1
1
1
2
2
2
1
4
1
4
4
1
1
1
2
1
1
2
4
4
4
1
3
3
2
1
1
2
4
4
1
1
1
1
2
2
2
3
3
Quantity
46/4835SX/DX
1
2
2
2
6
2
2
2
1
1
1
1
2
2
2
1
4
1
4
4
1
1
1
2
1
1
2
4
4
4
1
3
3
2
1
1
2
4
4
1
1
1
1
2
-
907807/HP1002
Deluxe Options
24
23
27
22
31
25
28
8
26
30
33
131362x.cpt
907807/HP1002
57
PRINTED IN USA
Ref.
No.
8
22
23
24
25
26
27
28
30
31
33
Part
No.
132161
070648
650630
654046
132367
650959
654002
071401
132244
651307
071401
132341
135362
067750
651308
651307
132368
650294
132348
067750
651308
651307
132369
650294
135361
132429
127360
PRINTED IN USA
Quantity
Deluxe Options
Description
SEAT/SUSPENSION
NUT/FLANGED LOCK
WASHER/PLAIN 7/16
ASSEMBLY/TOOLBOX
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 X 1-1/2
WASHER/FLAT 1/4
HINGE
SCREW/PHILLIPS PAN HEAD 1/4 X 1/2
COVER/TOOLBOX
CONSOLE/LEFT
NUT/SPEED
SUPPORT/CONSOLE
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 x 3/8
CONSOLE/RIGHT
NUT/SPEED
SUPPORT/CONSOLE
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 x 3/8
FOAM/LEFT ROPS
FOAM/RIGHT ROPS
BUSHING/PIVOT
58
1
4
2
2
1
2
2
2
1
6
6
1
1
6
4
2
1
3
1
6
4
2
1
3
1
1
4
907807/HP1002
SL46/4835 SKID LOADERS - RESTRAINT BAR
131323.png
907807/HP1002
59
PRINTED IN USA
SL46/4835 SKID LOADERS - RESTRAINT BAR
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
Part
No.
056937
067950
068034
078723
078730
078734
078942
121582
121610
128316
128979
128984
650551
PRINTED IN USA
Quantity
46/4835
Description
WASHER/FLAT 25/32
RING/EXTERNAL RETAINING
SPRING ASSEMBLY/ACTUATOR
SHAFT/PIVOT
COVER/PIVOT
SPRING/COMPRESSION
BAR/RESTRAINT
PIVOT/UPPER
BEARING/BRONZE
BRACKET ASSEMBLY/RIGHT
BRACKET ASSEMBLY/LEFT
8
4
4
2
2
2
2
1
2
12
2
2
2
60
907807/HP1002
SL46/4835 SKID LOADERS - SOUND SUPPRESSION
1
2
No
Washer
used
here.
3
4
134096x.cpt
907807/HP1002
61
PRINTED IN USA
Ref.
No.
1
2
3
4
Part
No.
131769
132288
136128
132078
136128
132167
132288
135374
PRINTED IN USA
Quantity
46/4835
Description
PAD/SEAT BACK
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 5/16 X 1 (Do Not Overtighten)
FASTENER/PANEL SNAP-IN
HEADLINER
CLIP/HEADLINER
PAD
62
1
1
5
1
9
1
3
1
907807/HP1002
Deluxe Options
5
12
11
2
12
12
1
12
10
7
20
6
Remove at perforation to fit
4635 model engine covers
3
4
8
13
16
15
19
14
9
134097x1.cpt
907807/HP1002
63
PRINTED IN USA
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
19
20
Part
No.
132335
132288
651363
132078
136128
135573
135572
132167
132288
135375
135394
070648
650315
135363
135464
132295
651307
071401
132296
651307
071401
133030
135366
135463
135374
135615
135617
135649
PRINTED IN USA
Quantity
Deluxe Options
Description
PAD/SEATBACK (INSIDE)
WASHER/BLACK PLATING 3/8
HEADLINER
PAD/CROSSMEMBER LEFT
PAD/CROSSMEMBER RIGHT
CLIP/HEADLINER
PAD/T-BAR COVER
PAD/LOWER REMOVABLE ROPS
NUT/FLANGED LOCK
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 1/4 X 1/2 (Do Not Overtighten)
PAD/FRONT RIGHT
PAD/FRONT LEFT
WINDOW/SIDE LEFT
WINDOW/SIDE RIGHT
BUSHING
PAD/RIGHT REAR
PAD/LEFT REAR
PAD
PAD/ENGINE COVER
PAD/GRILLE TO COOLER
PAD/FOAM DONUT
64
1
6
5
1
9
1
1
1
3
1
1
4
3
1
1
1
6
6
1
6
6
4
1
1
1
1
2
1
907807/HP1002
SL46/4835 SKID LOADERS - GRILLE & ENGINE COVER
19
9
7
9
8
12
8
13
11
10
11
20
14
1
5
17
18
16
6
4
2
15
3
9
134636x.cpt
907807/HP1002
65
PRINTED IN USA
SL46/4835 SKID LOADERS - GRILLE & ENGINE COVER
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Part
No.
131278
650585
654009
068034
131797
650834
650811
654009
134853
131940
131248
114665
131799
067847
135365
135380
131717
064260
128015
131913
131842
653034
132293
122485
064260
654024
132306
650573
654004
064260
132366
650573
064260
132493
091421
123501
122633
076147
135381
135600
651307
070634
PRINTED IN USA
Description
ASSEMBLY/GRILLE (Anti-seize compound)
WASHER/FLAT 1/2
MOUNT/LATCH
BOLT/CARRIAGE 1/2 X 1-1/2
WASHER/FLAT 1/2
BUSHING
LATCH
SPRING/COMPRESSION
ROD ASSEMBLY/LATCH
COVER/ENGINE
COVER/ENGINE
HINGE
WASHER/FLAT 1-1/32
BUMPER
NUT/JAM HEX 5/16
SPRING/GAS
STUD/BALL
WASHER/LOCK 5/16
BRACKET/LOCK
WASHER/FLAT 5/16
BRACKET/LOCK
CLIP/GAS SPRING
PIN/LOCK
WIRE
SLEEVE/CRIMP
CLAMP/HOSE
HOOD/AIR INTAKE
TUBE/FLANGED
SCREW/MACHINE PHILLIPS PAN HEAD 1/4 X 1/2
NUT/SERRATED LOCK, W/ FLANGE 1/4
66
Quantity
4635
Quantity
4835
1
2
2
2
1
1
1
2
2
1
1
1
1
2
1
2
4
2
3
3
3
1
2
1
1
1
1
1
1
1
1
1
2
1
1
2
1
1
1
3
3
1
2
2
2
1
1
1
2
2
1
1
1
1
2
1
2
4
2
3
3
3
1
2
1
1
1
1
1
1
1
1
1
2
1
1
2
1
1
1
3
3
907807/HP1002
SL46/4835 SKID LOADERS - ELECTRICAL - INSTRUMENT PANEL
50
135013x.cpt
907807/HP1002
67
PRINTED IN USA
SL46/4835 SKID LOADERS - ELECTRICAL - INSTRUMENT PANEL
Ref.
No.
Part
No.
Description
4635
Quantity
SX/SXT/DXT
Options
1
2
3
4
5
058805
067750
067785
067888
131842
CLAMP/HOSE
NUT/CLIP
HORN
GROMMET
1
3
2
3
1
3
2
3
1
3
1
2
4
6
7
071401
072340
650394
654044
650658
NUT/LOCK
HOUR METER
WASHER/LOCK #6
NUT/HEX #6
2
1
1
2
2
2
1
1
2
2
2
1
1
2
2
8
9
10
11
073036
074091
074579
075104
123817
SWITCH/LIGHT
TIE/NYLON
BREAKER/CIRCUIT
SWITCH/PUSH BUTTON
FUSE/15 AMP
1
2
-
1
1
2
-
1
1
2
1
1
12
13
14
15
16
076058
138177
088040
089071
089082
RELAY
ALARM/SEAT BELT LIGHT
HOUSING/DISPLAY
CLAMP/HALF
CUSHION
2
1
1
3
4
2
1
1
3
4
2
1
1
3
4
17
18
19
20
21
089083
121587
124089
127455
127963
PLATE/TOP
ACTUATOR
GROMMET
WIRE/HORN
SWITCH/RESTRAINT BAR
1
1
1
1
1
1
1
1
1
1
1
1
1
22
23
24
25
26
128738
129310
130032
130064
130342
BULB/LAMP
SOCKET/ELECTRIC
PANEL/INSTRUMENTATION
GASKET/LAMP HOUSING
WIRE ASSEMBLY/POWER
6
1
1
1
6
1
1
1
6
1
1
1
1
27
28
29
30
131018
131050
131159a
131688
131748
HARNESS ASSEMBLY/SEAT SWITCH
KEY TAG
GAUGE/TEMPERATURE (OIL)
SWITCH/IGNITION
KEY/IGNITION SWITCH (SET OF 2)
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
31
32
33
34
35
132200a
132364
134681
134977
135008
GAUGE/FUEL LEVEL
HARNESS/ACCESSORY
PLUG/PLASTIC 15/32
HARNESS ASSEMBLY/PANEL
DECAL/CONTROL PANEL
1
1
1
1
1
1
1
1
1
1
1
36
37
38
39
40
135241
650549
650550
650573
650687
SWITCH/PARK BRAKE
WASHER/LOCK #10
1
4
4
1
2
1
4
4
1
2
1
4
4
1
2
41
42
43
44
45
650848
651168
651212
651213
651308
WASHER/FLAT #6
SCREW/CAP SELF-TAPPING 3/8 X 3/4
SCREW/MACHINE #5 X 1/2
SCREW/PHILLIPS ROUND HEAD 1/4 X 3/4
4
1
4
4
3
4
1
4
4
3
4
1
4
4
3
46
47
48
49
50
651314
651343
651344
654042
130354
WASHER/STAR #6
SCREW/MACHINE ROUND HEAD 1/4 X 2-1/2
WASHER/STAR 3/8
SWITCH/SEAT (FOR USE WITH STANDARD SEAT)
4
4
2
1
1
4
4
2
1
1
4
4
2
1
-
132162
SWITCH/SEAT (FOR USE WITH DELUXE SEAT)
-
-
1
a) Order replacement bulb - part number 135761.
PRINTED IN USA
68
907807/HP1002
SL46/4835 SKID LOADERS - ELECTRICAL - ENGINE HARNESS/BATTERY
12
11 (Filter Bracket)
11 (Muffler Mount)
13
1
9 (ROPS Mount Gusset)
16 (Chaincase End Plate)
To Engine Block
10
(Engine
Flywheel Hydraulic
Tubes)
To Engine Block
(or optional
Disconnect
Switch)
5
To Chassis
4
10*
6
11 (Brake Valve Mount)
14
7
10**
To Engine Block
Optional
3
22
20
8
21
23
24
2
14
135015x2.cpt
907807/HP1002
69
PRINTED IN USA
SL46/4835 SKID LOADERS - ELECTRICAL - ENGINE HARNESS/BATTERY
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
16
Ref.
No.
20
21
22
23
24
Part
No.
136234
650648
650549
656100
055648
REF
122447
064260
654004
075028
656105
654042
054985
650490
654042
134852
135325
654042
081433
135010
058805
651168
128007
650426*
070634*
654002*
M12070**
076147
650487
131842
131460
650758
134588
135432
132063
055648
074091
077685
136226
650490
134852
Part
No.
091666
129363
650490
134852
091667
129385
129419
PRINTED IN USA
Quantity
46/4835
Description
HARNESS ASSEMBLY/ENGINE
NUT/HEX #10
WASHER/LOCK #10
NUT/HEX M5
TIE/WIRE
BATTERY/12V W/ HANDLE
ANGLE/BATTERY HOLD DOWN
WASHER/FLAT 5/16
CABLE/NEGATIVE BATTERY
SCREW/CAP HEX HEAD M8 X 25MM
WASHER/STAR 3/8
CABLE/SOLENOID
WASHER/STAR 3/8
CABLE/POSITIVE BATTERY
WASHER/STAR 3/8
COVER/TERMINAL
LOOM/BATTERY CABLE
CLAMP/TUBE
SCREW/CAP HEX WASHER HEAD SELF-TAPPING 3/8 X 3/4
CLAMP/TUBE
NUT/HEX 1/4
WASHER/FLAT 1/4
SPACER
CLAMP/HOSE
SOLENOID/STARTER
WASHER/STAR 1/4
MODULE/GLOW
TIE/WIRE
TIE/NYLON
ROD/BATTERY
CLAMP/TUBE
1
1
1
1
1
1
1
2
2
1
1
2
1
1
2
1
1
1
1
1
1
1
3
1
1
1
1
3
2
2
1
2
2
2
1
1
1
2
1
1
1
Quantity
Options
Description
SWITCH/DISCONNECT
BRACKET/SWITCH
PLATE/FACE
CABLE/SOLENOID
BOOT/BATTERY TERMINAL
1
1
2
2
1
1
2
70
907807/HP1002
SL46/4835 SKID LOADERS - ELECTRICAL - LIGHTS
7
8
7
8
6
51
6
50
9
51
9
5
10
3
11
3
10
3
11
2
3
10
1
1
2
134102x.gif
907807/HP1002
71
PRINTED IN USA
SL46/4835 SKID LOADERS - ELECTRICAL - LIGHTS
Quantity
Ref.
No.
Part
No.
Description
1
2
3
5
6
7
132046
LAMP/WORK
132047
LAMP/TAIL
132048
BEZEL
131941
HARNESS/REAR GRILLE
122011
LIGHT/WORK
122847
BRACKET/LIGHT
650687
070648
NUT/FLANGED LOCK
8
073687
GROMMET
9
076147
064260
10
132285
CLIP/SINGLE
064260
11
132286
CLIP/DOUBLE
064260
50
135038
PLATE/LIGHT COVER
51
135039
PLATE/PLATE HOLDER
650687
064260
Ref #1 - Order replacement bulb part number 122488.
Ref #2 - Purchase replacement bulb #1156 locally.
PRINTED IN USA
72
4635
Quantity
46/4835
SX/SXT/DXT
1
2
2
2
2
2
4
1
2
2
2
2
2
2
2
4
4
2
2
-
907807/HP1002
SECTION NOTES
907807/HP1002
73
PRINTED IN USA
SL46/4835 SKID LOADERS - DECALS
illustrated reference number. Find the part number,
description and quantity. Refer to the illustration for
replacement locations. Refer to Safety chapter of the
Operator’s Manual for information on the safety
decals.
GENERAL INFORMATION
CAUTION
ALWAYS follow safety precautions on decals.
Replace decals if they become damaged or if
the unit is repainted. If repainting, BE SURE
that all applicable decals are affixed in their
proper locations.
NEW DECAL APPLICATION
Surfaces MUST be free of dirt, dust, grease and
foreign material before applying the decal. Remove
smaller portion of decal backing paper and apply the
exposed adhesive to the clean surface, maintaining
proper position and alignment. Peel off remaining
backing paper and apply hand pressure to smooth out
the decal surface.
Decal location information assists in the selection
and application of new decals, in the event the
original decals become damaged or the machine is
repainted.
For decal replacement compare the location
photographs to your machine BEFORE starting to
refinish. Check off each required decal using the
DECAL KITS
PAINT FINISH
Language specific decal repaint kits may be
ordered using the following part numbers:
Use list below to order paint:
135714
135715
135716
135717
135718
135719
906213
906315
906317
906214
906316
906318
906323
English
German
French
Spanish
Italian
Portuguese
One Gallon Yellow
One Gallon Red (Optional Color)
One Gallon Charcoal Grey
6 (12 oz. Spray Cans) Yellow
6 (12 oz. Spray Cans) Red (Optional Color)
6 (12 oz. Spray Cans) Grey
One Quart Charcoal Grey
Specific decal part numbers for type of model,
control option and the Gehl logo must be
ordered separately from page 76.
PRINTED IN USA
74
907807/HP1002
Ref.
No.
Part
No.
Description
4635/SX
Quantity
46/4835 Turbo
Optional
1
2
3
4
6
137545
072794
072797
130297
073075
REFLECTOR/RED
DECAL/HYDRAULIC OIL
DECAL/DIESEL FUEL
DECAL/HYDRALOC™
DECAL/TURTLE-RABBIT
2
1
1
1
1
2
1
1
1
1
2
1
1
9
10
11
12
13
091035
091050
093202
L65922
093367
DECAL/DANGER
DECAL/DANGER ROTATING COMPONENT
DECAL/ELECTRICAL CONTACT
DECAL/OPERATORS MANUAL
DECAL/WARNING MANUAL
1
1
1
1
1
1
1
1
1
1
1
-
14
15
16
17
19
093474
093475
093477
093479
129132
DECAL/WARNING-GENERAL
DECAL/WARNING CARRY LOAD LOW
DECAL/ROPS LOCK
DECAL/LOAD LOW
DECAL/LIFT ARM
1
1
1
1
1
1
1
1
1
1
-
21
22
24
28
29
122718
122745
094951
135184
132018
DECAL/WARNING
DECAL/WARNING GAS CYLINDERS
DECAL/MADE IN USA
DECAL/FILTER SELECTION
DECAL/SERVICE
1
1
1
1
1
1
1
1
1
1
1
1
1
30
33
34
35
37
132139
132166
121030
073458
132294
DECAL/TIE DOWN
TAG/RIP CORD
STRIP/NON-SKID SURFACE
STRIP/NON-SKID SURFACE
RING
4
1
3
1
1
4
1
3
1
1
4
1
3
1
1
38
40
41
42
51
122290
129130
129258
137660
L65928
DECAL/GEHL
DECAL/CAUTION, DO NOT OPEN
DECAL/WARNINGS
DECAL/IMPORTANT, ETHER
DECAL/PERSONLIFT
1
1
1
1
1
1
1
1
1
1
1
-
Use the parts lists on page 75 and page 76 to order
decals for your model of Skid Loader. Pages 77-80
show decal locations on the loaders.
Hydraloc is a trademark of the Gehl Company.
907807/HP1002
75
PRINTED IN USA
4635 Model Designation Decals
Ref.
No.
25
Part
No.
134940
Quantity
4635
Description
DECAL/4635
2
SX/SXT Model Designation Decals
Ref.
No.
25
Part
No.
Description
4635SX
Quantity
4635SXT
4835SXT
134939
134938
134941
134969
134970
DECAL/4635 SX
DECAL/4635 SXT
DECAL/4835 SXT
DECAL/4635 SX (OPTIONAL LIGHT GREY)
DECAL/4635 SXT (OPTIONAL LIGHT GREY)
2
2
-
2
2
2
-
134972
DECAL/4835 SXT (OPTIONAL LIGHT GREY)
-
-
2
DXT Model Designation Decals
Ref.
No.
25
Part
No.
134965
134964
134971
134973
Quantity
Description
4635DXT
4835DXT
2
2
-
2
2
DECAL/4635 DXT
DECAL/4835 DXT
DECAL/4635 DXT (OPTIONAL LIGHT GREY)
DECAL/4835 DXT (OPTIONAL LIGHT GREY)
Gehl Decals
Ref.
No.
18
Part
No.
Description
4635/SX
Quantity
46/4835 Turbo
Optional
36
122616
122617
122432
122290
132016
DECAL/GEHL
DECAL/GEHL (LIGHT GREY)
DECAL/GEHL
DECAL/GEHL (LIGHT GREY)
DECAL/TURBO
2
1
-
2
1
2
2
1
-
52
132187
122296
DECAL/TURBO (LIGHT GREY)
DECAL/GEHL MAX (LIGHT GREY)
-
-
2
2
20
Control Decals
Ref.
No.
Part
No.
Description
T-Bar
Quantity
Hand/Foot
Dual Hand
43
45
46
47
48
134060
123380
123381
072853
072854
DECAL/FORWARD
DECAL/LIFT
DECAL/TILT
DECAL/LIFT TILT
DECAL/TRACTION
1
1
2
1
1
-
-
49
50
132395
132396
DECAL/LEFT CONTROL
DECAL/RIGHT CONTROL
-
-
1
1
PRINTED IN USA
76
907807/HP1002
3
17
51
40
*
9
28
42
29
10
30
* Location of Deutz supplied Engine Service Decal.
Decal does not have a Gehl Part Number.
2
30
907807/HP1002
77
PRINTED IN USA
34
37
33
35
38
20
1
1
11
48
14
4
47
6
PRINTED IN USA
78
907807/HP1002
14
24
12
11
Decal Location on Deluxe Interior Loaders.
13
16
12
43
43
4
49
50
6
4
45
46
6
907807/HP1002
79
PRINTED IN USA
15
41
24
13
21
25
18
19
22
36
PRINTED IN USA
80
907807/HP1002
SECTION NOTES
907807/HP1002
81
PRINTED IN USA
Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Drive Motor and Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tandem Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Gear Pump - Standard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Gear Pump - High Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Main Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Self-Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Solenoid Valves - Lift and Tilt . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Solenoid Valve - Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Valve - High-Flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
PRINTED IN USA
82
907807/HP1002
SL46/4835 SKID LOADERS - LIFT CYLINDER
8
8
2
1
4
7
9
5
7
7
6
3
8
8
134368x.cpt
907807/HP1002
83
PRINTED IN USA
SL46/4835 SKID LOADERS - LIFT CYLINDER
Ref.
No.
Part
No.
Quantity
46/4835
Description
134368
CYLINDER /LIFT
1
075722
NUT/LOCK 7/8
2
134839a
TUBE/LIFT CYLINDER
3
134840a
ROD/LIFT CYLINDER
4
134841
PISTON
5
134842
GLAND/HEAD
6
121554
CAP/GLAND
7
134848
KIT/SEAL
8
134844
BUSHING/CONNEX
9
134843
SPACER
a) Includes (2) Ref. #8 - 134844 - Bushing/Connex.
PRINTED IN USA
1
1
1
1
1
1
1
1
4
1
84
907807/HP1002
SL46/4835 SKID LOADERS - TILT CYLINDER
8
8
3
2
1
7
7
4
7
5
8
6
9
8
134752x3.cpt
907807/HP1002
85
PRINTED IN USA
SL46/4835 SKID LOADERS - TILT CYLINDER
Ref.
No.
Part
No.
Quantity
46/4835
Description
135058
CYLINDER/TILT
1
075722
NUT/LOCK 7/8
2
134841
PISTON
3
135061a
TUBE/TILT CYLINDER
4
134847
GLAND/HEAD
5
121554
CAP/GLAND
6
135062b
ROD/TILT CYLINDER
7
134849
KIT/SEAL
8
131488
BUSHING/CONNEX
9
570002
FITTING/GREASE
a) Includes (1) Ref. #8 - 131488 - Connex Bushing.
b) Includes (2) Ref. #8 - 131488 - Connex Bushing.
PRINTED IN USA
1
1
1
1
1
1
1
1
4
1
86
907807/HP1002
SL46/4835 SKID LOADERS - DRIVE MOTOR & PARKING BRAKE
2
1
1
6
8
9 10
11
3
12
26
23
24
13
16
7
25
15
19
18
17
14
5
4
21 & 22
133966x.cpt
907807/HP1002
87
PRINTED IN USA
SL46/4835 SKID LOADERS - DRIVE MOTOR & PARKING BRAKE
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
21
22
23
24
25
26
Part
No.
133966
135336
135351
135352
135353
135338
135354
135339
135340
135341
135342
135343
135344
135345
135355
135346
135347
135348
135349
135350
135357
135687
132638
138200
138405
138406
PRINTED IN USA
Quantity
46/4835
Description
MOTOR/DRIVE WITH PARKING BRAKE
BLOCK/CYLINDER
KIT/REPAIR
CAM
COVER/VALVING
KIT/SEAL
SUPPORT
BEARING
BEARING
SET OF SHIMS
RING
RING/SNAP
SEAL/ENVIRONMENT
SHAFT
BRAKE/DISC
PISTON/BRAKE
WASHER/SPRING
RING/SNAP
SHAFT
KIT/DISC BRAKE
KIT/SEAL MOTOR AND BRAKE
KIT/TOOL MSE02
PLUG/RUBBER
O-RING
O-RING
PROTECTOR
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
88
907807/HP1002
SL46/4835 SKID LOADERS - TANDEM PUMP
Tandem Pump/Gear Pump End
15
30
38
13
26
38
14
34
35
17
33
32
16
31
3
6
37
39
20*
39* 28
7
13
39
4
8
24*
21*
22*
23*
28
10
25*
28
39*
5
19*
28
18
39
9
37
3
27
39
39
11
3911
12
29
2 36 1
Asterisk (*) reference numbers are included
in reference number (18) housing assembly.
131975.tif
907807/HP1002
89
PRINTED IN USA
Ref.
No.
Part
No.
Description
Quantity
136389a
PUMP/TANDEM GEAR PUMP END
135029b
PUMP/TANDEM GEAR PUMP END
1
123067
NUT/JAM
2
123069
WASHER/SEAL
3
123122
SCREW/CAP HEX SOCKET HEAD #12 X 1
4
123070
KIT/ROTATING
5
136978a
PISTON/SERVO
128105b
PISTON/SERVO
6
128106
FOLLOWER/PISTON
7
123073
PLATE/COVER
8
127989
GASKET
9
123079
PLATE/COVER
10
123080
PLATE/CAM
11
060745
BEARING/RACE THRUST
12
060746
BEARING/THRUST
13
132647
VALVE/RELIEF 5500 PSI
14
650731
15
650742
16
123123
SCREW/CAP HEX SOCKET HEAD #12 X 1-1/2
17
123084
PLATE/VALVE
18
136979a
ASSEMBLY/HOUSING
ASSEMBLY/HOUSING
128112b
19
055306
BEARING
20
136985
PLUG/SAE04
21
136980a
CRADLE
128166b
CRADLE
PIN/DOWEL
22
127679a
128130b
PIN/DOWEL
23
136981a
BUSHING/CAM
132646b
BUSHING/CAM
24
136994
SCREW/CAP BUTTON HEAD
25
136982a
SCREW/CAP
136984b
SCREW/CAP
26
136983a
ASSEMBLY/BACKPLATE
132653b
ASSEMBLY/BACKPLATE
27
123129
SHAFT/DRIVE
28
131529
PLUG/SAE08
29
123094
SPACER
30
135445
ADAPTER ASSEMBLY/CHARGE
31
132649
ASSEMBLY/CONTROLLER
32
127990
KEY
33
136986
SEAL/WIPER
34
136987
KIT/GEROTOR SEAL
35
136995a
PLUG/SAE08
132650b
PLUG/SAE08
36
123110
WASHER
37
650854
WASHER/FLAT #12
38
136988
WASHER
39
128108
KIT/SEAL
a) SN300317 & later - SL4635; SN400254 & later - SL4835
b) Before SN300317 - SL4635; Before SN400254 - SL4835
PRINTED IN USA
90
1
1
1
1
8
1
1
1
1
1
1
1
1
2
1
2
2
2
6
1
1
1
1
1
1
1
2
2
1
1
2
2
2
1
1
1
4
1
1
1
1
1
1
1
1
1
8
4
1
907807/HP1002
Tandem Pump/Engine End
29
38
13
14
39
36
37
33
13
16
31
32
40
15
30
3
4
6
35
40
40*
19*
28
8
23
20
7
10
21
24
22
28
28
40*
5
28
18*
40
17
9
35
26
3
40
11
11
27
40
1
12
2 34
40
29**
Asterisk (*) reference numbers are included
in reference number (17) housing assembly.
Double asterisk (**) reference number is
included in seal kit reference number (40).
131974x.cpt
907807/HP1002
91
PRINTED IN USA
Ref.
No.
Part
No.
Quantity
46/4835
Description
136388a
PUMP/TANDEM GEAR ENGINE END
134286b
PUMP/TANDEM GEAR ENGINE END
1
123067
NUT/JAM
2
123069
WASHER/SEAL
3
123122
SCREW/CAP HEX SOCKET HEAD #12 X 1
4
123070
KIT/ROTATING
5
136978a
PISTON/SERVO
128105b
PISTON/SERVO
6
128106
FOLLOWER/PISTON
7
123073
PLATE/COVER
8
127989
GASKET
9
123079
PLATE/COVER
10
123080
PLATE/CAM
11
060745
BEARING/RACE THRUST
12
060746
BEARING/THRUST
13
132647
VALVE/RELIEF 5500 PSI
14
650535
15
123123
SCREW/CAP HEX SOCKET HEAD #12 X 1-1/2
16
123084
PLATE/VALVE
17
137017a
ASSEMBLY/HOUSING
132648b
ASSEMBLY/HOUSING
18
055306
BEARING
19
136985
PLUG/SAE04
20
136980a
CRADLE
128166b
CRADLE
21
127679a
PIN/DOWEL
PIN/DOWEL
128130b
22
136981a
BUSHING/CAM
132646b
BUSHING/CAM
23
136994
SCREW/CAP BUTTON HEAD
24
136982a
SCREW/CAP
136984b
SCREW/CAP
25
137016a
ASSEMBLY/BACKPLATE
137015b
ASSEMBLY/BACKPLATE
26
123087
SHAFT/DRIVE
27
060748
WASHER
28
131529
PLUG/SAE08
29
123093
SEAL/SHAFT
30
132649
ASSEMBLY/CONTROLLER (Includes #31 and #32)
31
127990
KEY
32
136986
SEAL/WIPER
33
136995a
PLUG/SAE08
PLUG/SAE08
132650b
34
123110
WASHER
35
650854
WASHER/FLAT #12
36
123114
COUPLER
37
132248
O-RING
38
650433
39
654009
WASHER/FLAT 1/2
40
128108
KIT/SEAL
a) SN300317 & later - SL4635; SN400254 & later - SL4835
b) Before SN300317 - SL4635; Before SN400254 - SL4835
PRINTED IN USA
92
1
1
1
1
8
1
1
1
1
1
1
1
1
2
1
2
4
6
1
1
1
1
1
1
1
2
2
1
1
2
2
2
1
1
1
1
4
1
1
1
1
1
1
1
8
1
1
2
2
1
907807/HP1002
SL46/4835 SKID LOADERS - GEAR PUMP - STANDARD
4635 and SX Models
7
8
1
3
1
5
6
4
1
2
sgearpmp.cpt
907807/HP1002
93
PRINTED IN USA
SL46/4835 SKID LOADERS - GEAR PUMP - STANDARD
Ref.
No.
1
2
3
4
5
6
7
8
Part
No.
134878
134927
130034
130033
134924
134926
134925
603024
130050
PRINTED IN USA
Quantity
4635/SX/4835SXT
Description
PUMP/GEAR 1.77 SINGLE
KIT/SEAL
ASSEMBLY/BACK PLATE
ASSEMBLY/FRONT PLATE
ASSEMBLY/BODY
ASSEMBLY/DRIVE GEAR
GEAR/IDLER
SCREW/CAP
WASHER
1
1
1
1
1
1
1
8
4
94
907807/HP1002
SL46/4835 SKID LOADERS - GEAR PUMP - HIGH FLOW
DX Models
14
13
12
2
2
2
10
2
2
2
2
7
9
11
6
4
2
2
2
2
2
3
2
1
5
2
8
dblgearp.bmp
907807/HP1002
95
PRINTED IN USA
SL46/4835 SKID LOADERS - GEAR PUMP - HIGH FLOW
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Part
No.
129706
130034
130059
130036
130041
130039
090047
130040
130046
130035
130037
130038
130033
130050
130055
PRINTED IN USA
Quantity
46/4835DXT
Description
PUMP/GEAR 1.77/1.02 DOUBLE
ASSEMBLY/BACK PLATE
KIT/SEAL DOUBLE PUMP
ASSEMBLY/BODY 1.02
GEAR/SLIP FIT 1.02
GEAR/IDLER 1.02
KEY
PLATE/ADAPTER 20/10
PLUG/RUBBER
ASSEMBLY/BODY 1.77
GEAR/DRIVE 1.77
GEAR/IDLER 1.77
ASSEMBLY/FRONT PLATE
WASHER
1
1
1
1
1
1
1
1
1
1
1
1
1
4
8
96
907807/HP1002
SL46/4835 SKID LOADERS - MAIN CONTROL VALVE
2
3
1
4
5
8
7
10
6
9
11
132210x3.cpt
907807/HP1002
97
PRINTED IN USA
SL46/4835 SKID LOADERS - MAIN CONTROL VALVE
Ref.
No.
Part
No.
Description
T-Bar
Quantity
Dual Hand
Hand/Foot
132692
132210
136054
132211
080331
VALVE/CONTROL
VALVE/CONTROL
VALVE/CONTROL
VALVE/RELIEF
SECTION/INLET
1
1
1
1
1
1
1
1
1
5
132694
132695
136318
133064
080333
SECTION/LIFT
SECTION/TILT
SECTION/TILT
SECTION/TILT
SECTION/AUXILIARY
1
1
1
1
1
1
1
1
1
6
7
8
9
10
080330
135371
135368
135369
127629
SECTION/OUTLET
VALVE/RELIEF
POPPET/LOAD CHECK
SPRING
KIT/DETENT
1
1
3
3
1
1
1
3
3
1
1
1
3
3
1
11
080327
KIT/SEAL
1
1
1
1
2
3
4
PRINTED IN USA
98
907807/HP1002
SL46/4835 SKID LOADERS - SELF-LEVEL VALVE
8
9
7
10
10
3
4
2
11
10
10
10
1
5
6
10
6
9
7
10
8
10
128844x.cpt
907807/HP1002
99
PRINTED IN USA
SL46/4835 SKID LOADERS - SELF-LEVEL VALVE
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
Part
No.
135367
080808
080809
080810
080811
129004
080813
088471
088472
088473
129066
089961
PRINTED IN USA
Quantity
46/4835
Description
VALVE/SELF-LEVELING
PIN
CAP/ADJUSTMENT
NUT
SCREW/SET
PLUG
PLUG
SPRING
PLUG
CHECK/LOAD
KIT/SEAL
SPRING
1
1
1
1
1
1
2
2
2
1
1
1
100
907807/HP1002
SL46/4835 SKID LOADERS - SOLENOID VALVE - LIFT/TILT
2
3
1
4
129314.cpt
907807/HP1002
101
PRINTED IN USA
SL46/4835 SKID LOADERS - SOLENOID VALVE - LIFT/TILT
Ref.
No.
1
2
3
4
Part
No.
129314
138344
122840
129326
121897
PRINTED IN USA
Quantity
46/4835
Description
VALVE/SOLENOID
VALVE BODY/STEEL
CARTRIDGE
COIL
KIT/SEAL
1
1
1
1
1
102
907807/HP1002
SL46/4835 SKID LOADERS - SOLENOID VALVE - BRAKE
3
1
4
2
129063.cpt
907807/HP1002
103
PRINTED IN USA
SL46/4835 SKID LOADERS - SOLENOID VALVE - BRAKE
Ref.
No.
Part
No.
Quantity
46/4835
Description
129063
VALVE/SOLENOID
1
130167
COIL
2
132199
KIT/SEAL
3
130166
CARTRIDGE
4
REFa
BODY
a ) Valve body not serviced separately.
PRINTED IN USA
1
1
1
1
1
104
907807/HP1002
SL46/4835 SKID LOADERS - VALVE - HIGH-FLOW
1
4
3
3
5
6
2
7
134599x1.cpt
907807/HP1002
105
PRINTED IN USA
SL46/4835 SKID LOADERS - VALVE - HIGH-FLOW
Ref.
No.
1
2
3
4
5
6
7
Part
No.
134599
135457
135458
131522
135459
135460
135461
135462
PRINTED IN USA
Quantity
46/4835
Description
VALVE/DX
ASSEMBLY/DETENT
BODY/VALVE
PLUG/SAE12
VALVE/RELIEF (ADJUST TO 2500 PSI ± 50 AT FULL THROTTLE)
SPOOL
ASSEMBLY/FLANGE
KIT/SEAL (Includes all seals for valve assembly and relief)
106
1
1
1
2
1
1
1
1
907807/HP1002
Backhoe Mount Kit 807184. . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Crossmember Auxiliary Tube Kit 807233 . . . . . . . . . . . . . . . . . . . . 109
Backhoe Hydraulics Kit 807193 (4635) and 807231 (4835) . . . . . . . . . . . 110
All-Tach Kit 807825 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Frame Reinforcement Kit 807238 . . . . . . . . . . . . . . . . . . . . . . . . 112
Rear Counterweight Kit 807243 . . . . . . . . . . . . . . . . . . . . . . . . . 112
Gehl Quick-Tach™ Kit 807230. . . . . . . . . . . . . . . . . . . . . . . . . . 113
Backhoe 1/2 Mount for 9HD2 Backhoe Kit 806293 . . . . . . . . . . . . . . . 114
Rearview Mirror Kit 806894 . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Backup Alarm Kit 807190 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Cab Heater Kit 807824 (see also Side-Mounted below) . . . . . . . . . . . . . 116
Dome Light Kit 807278 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Horn Kit 806923 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Centrifugal Pre-Cleaner Kit 808204 . . . . . . . . . . . . . . . . . . . . . . . 118
Parker Coupler Kit 807050 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Engine Auto Shutdown System Kit 806918 . . . . . . . . . . . . . . . . . . . 119
Strobe Light Kit 805803 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Dual Flasher Kit 806920 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Front Door Kit 807292 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Airboss Solid Segmented Tire Repair Parts. . . . . . . . . . . . . . . . . . . . 122
Self-Level Valve Kit 807336 (4635) . . . . . . . . . . . . . . . . . . . . . . . 122
Double Gas Spring Kit 807376 . . . . . . . . . . . . . . . . . . . . . . . . . . 123
4635 T-Bar and Dual Hand Auxiliary Hydraulics Kit 807239 . . . . . . . . . . 111
Tilt Cylinder Lock Valve Kit 135564. . . . . . . . . . . . . . . . . . . . . . . 123
Impact Resistant Front Door Kit 807330 . . . . . . . . . . . . . . . . . . . . . 124
Work Taillight Kit 807293 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Deluxe Interior Kit 807429 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Side-Mounted Cab Heater Kit 807833 . . . . . . . . . . . . . . . . . . . . . . 126
Other Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
PRINTED IN USA
108
907807/HP1002
SL46/4835 SKID LOADERS - ACCESSORIES
3
6
1
5
4
7
8
3
2
Backhoe Mount Kit 807184
7
Ref.
No.
Part
No.
Qty.
Req.
REF
807184
KIT/BACKHOE MOUNTING . . . . . . . . . . 1
5
134966
WASHER/FLAT 1/2 . . . . . . . . . . . . . . . . 36
1
2
071706
132708
NUT/LOCK 1/2 . . . . . . . . . . . . . . . . . . . . 18
BRACKET/MOUNTING . . . . . . . . . . . . . . 1
6
7
650503
650569
SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . . 8
SCREW/CAP 1/2 X 1-3/4 . . . . . . . . . . . . 8
3
4
134764
134765
BRACE/END . . . . . . . . . . . . . . . . . . . . . . 2
REINFORCEMENT . . . . . . . . . . . . . . . . . 1
8
650585
SCREW/CAP 1/2 X 2 . . . . . . . . . . . . . . . 2
Description
Ref.
No.
Part
No.
Description
Connect to
Tee under
Lift Arm on
left side.
2
3
Qty.
Req.
1
4
Crossmember Auxiliary
Tube Kit 807233
Ref.
No.
Part
No.
REF
807233
KIT/HYDRAULIC DISCONNECT . . . . . . 1
3
131952
COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
1
134482
TUBE/AUXILIARY OUTER. . . . . . . . . . . 1
4
131953
COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
2
134484
TUBE/AUXILIARY INNER . . . . . . . . . . . 1
907807/HP1002
Description
Qty.
Req.
Ref.
No.
109
Part
No.
Description
Qty.
Req.
PRINTED IN USA
Backhoe Hydraulics Kit
807193 (SL4635),
Backhoe Hydraulics Kit
807231 (SL4835)
3
5
8
1
4
2
Ref.
No.
Part.
No.
REF
1
Qty.
Req.
Ref.
No.
Part.
No.
807193
131952
KIT/HYDRAULIC COUPLERS . . . . . . . . 1
COUPLER/MALE (FLAT-FACED) . . . . 1
REF
1
807231
131952
KIT/ HYDRAULIC COUPLERS . . . . . . . 1
COUPLER/MALE (FLAT-FACED) . . . . 1
2
3
131953
134798
COUPLER/FEMALE (FLAT-FACED) . . 1
2
3
131953
134807
COUPLER/FEMALE (FLAT-FACED) . . 1
TUBE/AUXILIARY HYD. INNER . . . . . . 1
4
5
134799
133077
BRACKET/AUXILIARY TUBE . . . . . . . . 1
4
5
134808
133077
TUBE/AUXILIARY HYD. OUTER . . . . . 1
BRACKET/AUXILIARY TUBE . . . . . . . . 1
650573
131842
8
058610
4635
Description
BOLT/CARRIAGE 5/16 X 1 . . . . . . . . . 2
NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2
650573
131842
TEE/SWIVEL JIC10 . . . . . . . . . . . . . . . . 2
8
058610
All-Tach™ Kit 807825
4835
Description
Qty.
Req.
BOLT/CARRIAGE 5/16 X 1 . . . . . . . . . 2
NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2
TEE/SWIVEL JIC10 . . . . . . . . . . . . . . . . 2
9
1
12
10
6
8
3
7
2
5
11
4
Ref.
No.
Part
No.
REF
807825
KIT/ALL-TACH SL46/4835 . . . . . . . . . . . 1
1
2
135160
134219
ALL-TACH BODY . . . . . . . . . . . . . . . . . . 1
PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
3
134594
ROD/PUSH . . . . . . . . . . . . . . . . . . . . . . . . 2
651542 SCREW/CAP 1/2 X 2-3/4” . . . . . . . . . . 2
4
5
123554
134874
Description
Qty.
Req.
Ref.
No.
8
Part
No.
134707
068034
654009
9
Description
Qty.
Req.
SPRING/COMPRESSION . . . . . . . . . . . 2
NUT/LOCK 1/2” . . . . . . . . . . . . . . . . . . . 2
WASHER/FLAT 1/2” . . . . . . . . . . . . . . . 2
135300
PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
650492 SCREW/HEX HEAD 3/8 X 2-1/2” . . . . 2
SPRING/COMPRESSION . . . . . . . . . . . 2
ADAPTER/ROD . . . . . . . . . . . . . . . . . . . . 2
10
067847 NUT/LOCK 3/8” . . . . . . . . . . . . . . . . . . . 2
651364
SCREW/SOCKET HEAD 1/2 X 4” . . . . . 2
137214
WASHER/FLAT” . . . . . . . . . . . . . . . . . . 2
11
062756
PIN/SPRING. . . . . . . . . . . . . . . . . . . . . . . 2
651297
SCREW/CAP 3/8 X 1” . . . . . . . . . . . . . 2
12
570002
FITTING/GREASE . . . . . . . . . . . . . . . . . . 2
13
650846
SCREW/CAP 5/8 X 6”. . . . . . . . . . . . . . . 1
6
136036
HANDLE/RIGHT . . . . . . . . . . . . . . . . . . . 1
7
136037
HANDLE/LEFT . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN USA
110
907807/HP1002
4635 T-Bar/Dual Hand Auxiliary Hydraulics Kit 807239
27
26
Control Valve
16
28
17
17
25
8
11
16
9
23
24
7
5
6
22
1
21
17
5
10
15
6
16
2
3
18
4
8
20
19
Ref.
No.
Part
No.
REF
807239
1
135310
ASSY/PEDAL SUPPORT . . . . . . . . . . . . 1
650487 SCREW/CAP 5/16 X 1 . . . . . . . . . . . . . 3
2
3
4
Description
Qty.
Req.
Ref.
No.
KIT/AUXILIARY HYDRAULICS . . . . . . . 1
11
Part
No.
134760
650486
131842
Description
Qty.
Req.
BRACKET/CABLE . . . . . . . . . . . . . . . . . . 1
SCREW/CAP 5/16 X ¾. . . . . . . . . . . . . 2
NUT/SPIRALOCK 5/16 . . . . . . . . . . . . . 2
064260
NUT/LOCK NYLON INSERT 5/16. . . . 3
15
075236
654004
WASHER/FLAT 5/16 . . . . . . . . . . . . . . 3
16
079098
PLATE/TWIN COVER . . . . . . . . . . . . . . . 3
650568 SCREW/CAP 5/16 X 2 . . . . . . . . . . . . . 3
135309
ASSY/AUXILIARY PEDAL . . . . . . . . . . . 1
067847 NUT/LOCK NYLON INSERT 3/8 . . . . . 1
654024
064260
654006 WASHER/FLAT 3/8. . . . . . . . . . . . . . . . 1
135312
BAR/STOP . . . . . . . . . . . . . . . . . . . . . . . . 1
127360
BUSHING/PIVOT . . . . . . . . . . . . . . . . . . . 1
650692 SCREW/CAP 5/16 X 1-3/4. . . . . . . . . . 1
B11296
064260
WASHER/FLAT 11/32 . . . . . . . . . . . . . 1
5
6
115039
079614
7
121002 NUT/LOCK NYLON INSERT . . . . . . . . 4
065164
END/YOKE . . . . . . . . . . . . . . . . . . . . . . . . 2
8
650648 NUT/HEX 10-32. . . . . . . . . . . . . . . . . . . 2
127488
PIN/CLEVIS .19 . . . . . . . . . . . . . . . . . . . . 4
650551
CABLE/CONTROL . . . . . . . . . . . . . . . . . 1
CLAMP/CONDUIT . . . . . . . . . . . . . . . . . . 2
PIN/COTTER 3/32 X 3 . . . . . . . . . . . . . 4
654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 1
079126
CLAMP/TUBE 5/8 . . . . . . . . . . . . . . . . . . 3
18
19
131952
131953
COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
20
21
134464
134474
TUBE W/TEE . . . . . . . . . . . . . . . . . . . . . . 1
TUBE W/TEE . . . . . . . . . . . . . . . . . . . . . . 1
22
23
134483
134485
24
25
134621
134622
TUBE/AUXILIARY FRONT . . . . . . . . . . . 1
TUBE/AUXILIARY REAR . . . . . . . . . . . . 1
26
134698
HOSE/MP 5/8 X 48 . . . . . . . . . . . . . . . . . 2
27
074395
CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 1
088254
LEVER/VALVE AUXILIARY . . . . . . . . . . 1
067847
10
087974
JOURNAL/PIVOT . . . . . . . . . . . . . . . . . . 1
654006
28
111
WASHER/LOCK 5/16 . . . . . . . . . . . . . . 2
17
9
907807/HP1002
CAP/37 7/8 . . . . . . . . . . . . . . . . . . . . . . . 2
072580
NUT/LOCK NYLON INSERT 3/8 . . . . . 1
WASHER/FLAT 3/8. . . . . . . . . . . . . . . . 1
FITTING/STRAIGHT SAE10 JIC10 . . . 2
PRINTED IN USA
3
1
4
4
2
2
3
5
1
6
4
Frame Reinforcement Kit 807238
Ref.
No.
Part
No.
REF
807238
KIT/BACKHOE MOUNTING . . . . . . . . . . 1
4
134966
WASHER/FLAT 1/2 . . . . . . . . . . . . . . . . 24
1
2
071706
134764
NUT/LOCK 1/2 . . . . . . . . . . . . . . . . . . . . 12
BRACE/END . . . . . . . . . . . . . . . . . . . . . . 2
5
6
650503
650569
SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . . 8
SCREW/CAP 1/2 X 1-3/4 . . . . . . . . . . . . 4
3
135094
SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Description
Qty.
Req.
Ref.
No.
Part
No.
Qty.
Req.
Description
651380
651353
1
132681
651353
Rear Weight Kit 807243
Ref.
No.
Part
No.
Description
132681
Qty.
Req’d
Ref.
No.
Part
No.
Description
Qty.
Req’d
REF
807243
KIT/REAR WEIGHT. . . . . . . . . . . . . . . . . 1
2
130309
DECAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
1
135120
COUNTERWEIGHT . . . . . . . . . . . . . . . . . 1
3
068034
NUT/LOCK NYLON INSERT . . . . . . . . . 2
651380
SCREW/CAP 1 X 6” . . . . . . . . . . . . . . . 2
651353
WASHER/FLAT 1". . . . . . . . . . . . . . . . . 2
132681
NUT/LOCK NYLON INSERT 1-8 . . . . 2
PRINTED IN USA
112
907807/HP1002
Gehl Quick-Tach™ Kit 807230
7
6
5
4
3
1
2
Ref.
No.
Part
No.
REF
1
807230
134664
2
3
Ref.
No.
Part.
No.
KIT/GEHL QUICK-TACH™ . . . . . . . . . . 1
QUICK-TACH ‘35 SERIES . . . . . . . . . . . 1
4
5
065054
H8049
134899
PIN/TILT CYLINDER. . . . . . . . . . . . . . . . 2
650833 SCREW/CAP 5/16 X 3 . . . . . . . . . . . . . 2
6
121707
LINK/PIN LATCH . . . . . . . . . . . . . . . . . . . 2
064260 NUT/LOCK NYLON INSERT 5/16. . . . 2
114883
PIN/LATCH . . . . . . . . . . . . . . . . . . . . . . . . 2
7
128368
HANDLE ASSY/QUICK-TACH . . . . . . . . 1
650650 SCREW/CAP 1/2 X 3-1/2 . . . . . . . . . . . 1
650503
068034
907807/HP1002
Description
Qty.
Req.
SCREW/CAP 1/2 X 2-1/2 . . . . . . . . . . . 2
NUT/LOCK NYLON INSERT 1/2 . . . . . 2
8
113
Description
Qty.
Req.
PIN/ROLL 1/4 X 2 . . . . . . . . . . . . . . . . . . 2
SPRING . . . . . . . . . . . . . . . . . . . . . . . . . . 2
650846
SCREW/CAP 5/8 X 6 . . . . . . . . . . . . . . . 1
PRINTED IN USA
4
2
5
1
4
2
7
6
3
1
Backhoe 1/2 Mount Kit 806293 for
9HD2 Backhoes
Ref.
No.
Part
No.
REF
1
806293
061612
2
067847 NUT/LOCK 3/8. . . . . . . . . . . . . . . . . . . . 4
078368
SPRING/TENSION . . . . . . . . . . . . . . . . . 2
3
Description
Qty.
Req.
Ref.
No.
KIT/BACKHOE 1/2 MOUNT . . . . . . . . . . 1
PIN 1 X 2-5/8 . . . . . . . . . . . . . . . . . . . . . . 2
4
5
078493
MOUNT/BACKHOE RIGHT . . . . . . . . . . 1
650163 SCREW/CAP 3/4 X 1-3/4 . . . . . . . . . . . 3
096662
6
WASHER/FLAT 3/4. . . . . . . . . . . . . . . . 3
Part
No.
Description
Qty.
Req.
075208
LATCH. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
650490 SCREW/CAP 3/8 X 1 . . . . . . . . . . . . . . 2
650493 SCREW/CAP 3/8 X 2-3/4 . . . . . . . . . . . 2
075211
HANDLE/RIGHT . . . . . . . . . . . . . . . . . . . 1
078492
MOUNT/BACKHOE LEFT . . . . . . . . . . . 1
650163 SCREW/CAP 3/4 X 1-3/4 . . . . . . . . . . . 3
7
096662 WASHER/FLAT 3/4. . . . . . . . . . . . . . . . 3
075212
HANDLE/LEFT . . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
REF
1
806894
132353
KIT/REAR VIEW MIRROR . . . . . . . . . . . 1
MIRROR . . . . . . . . . . . . . . . . . . . . . . . . . . 1
2
651259
SCREW/CAP THREAD CUTTING
#10 X 7/8 . . . . . . . . . . . . . . . . . . . . . . . . . 2
Rearview Mirror Kit 806894
Description
Qty.
Req.
Approximate
Mirror Location
PRINTED IN USA
114
907807/HP1002
Backup Alarm Kit 807190
ROPS (REAR VIEW)
2
1
5
CHASSIS CROSSMEMBER
4
3
PLUG FROM MAIN
WIRING HARNESS
8
CONTROL LINKAGE
7
6
Ref.
No.
Part
No.
REF
807190
1
135818
BRACKET/ALARM . . . . . . . . . . . . . . . . . 1
071706 NUT/CENTER LOCK 1/2 . . . . . . . . . . . 1
2
135727
ALARM/BACKUP . . . . . . . . . . . . . . . . . . . 1
650758 BOLT/CARRIAGE 1/4X3/4. . . . . . . . . . 2
Description
Qty.
Req’d
KIT/BACKUP ALARM . . . . . . . . . . . . . . . 1
3
134588 NUT/FLANGE 1/4 . . . . . . . . . . . . . . . . . 2
135722
HARNESS/BACKUP . . . . . . . . . . . . . . . . 1
4
5
063064
055648
6
135726
SWITCH/ALARM . . . . . . . . . . . . . . . . . . . 2
650848 WASHER/FLAT #6 . . . . . . . . . . . . . . . . 4
7
134763
BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . 2
650758 BOLT/CARRIAGE 1/4X3/4. . . . . . . . . . 4
8
CLIP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
TIE/WIRE . . . . . . . . . . . . . . . . . . . . . . . . . 5
134588 NUT/FLANGE 1/4 . . . . . . . . . . . . . . . . . 4
132274
HARNESS/POWER TAP . . . . . . . . . . . . 1
907807/HP1002
115
PRINTED IN USA
49
Cab Heater Kit 807824
10
9
2
48
4
5
7
4
6
4
6
1
3 8
2
1
2
44
37
35
38
36
39
34
47
40
33
45
32
41
30
43 42 31
Ref.
No.
Part
No.
Ref.
No.
Part.
No.
REF
807824
1
2
135379
132503
KIT/HEATER CAB SL46/4835 . . . . . . . . 1
38
135280
COIL/HEATER . . . . . . . . . . . . . . . . . . . . . 1
ADAPTER/90°. . . . . . . . . . . . . . . . . . . . . 2
HOSE/LOW PRESSURE 5/8 X 54 . . . . 2
39
40
134674
134675
HARNESS/HEATER . . . . . . . . . . . . . . . . 1
MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
3
4
132504
095955
VALVE/BALL . . . . . . . . . . . . . . . . . . . . . . 1
CLAMP/HOSE #10 . . . . . . . . . . . . . . . . . 4
41
42
135281
134677
MOUNT/MOTOR . . . . . . . . . . . . . . . . . . . 1
WHEEL/BLOWER . . . . . . . . . . . . . . . . . . 1
5
058805
CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 1
650758 BOLT/CARRIAGE 1/4 X 3/4 . . . . . . . . 1
43
44
134678
134679
RESISTOR/3-SPEED . . . . . . . . . . . . . . . 1
HARNESS/SWITCH . . . . . . . . . . . . . . . . 1
45
135286
133062
BRACKET/TUBE . . . . . . . . . . . . . . . . . . . 1
SWITCH/FAN (not shown - ns) . . . . . . 1
134588
654002
Description
Qty.
Req.
NUT/SPIRALOCK 1/4 . . . . . . . . . . . . . 1
WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 1
Description
Qty.
Req.
6
7
132362
136195
FITTING/STRAIGHT M18 X 1.5 . . . . . . 2
HEATER . . . . . . . . . . . . . . . . . . . . . . . . . . 1
072854
072853
DECAL/TRACTION (ns) . . . . . . . . . . . . . 1
DECAL/LIFT TILT (ns) . . . . . . . . . . . . . . 1
8
650510 SCREW/THREAD CUT 5/16 X 1/2 . . . 2
132148
BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
134060
123380
DECAL/FORWARD-R (ns) . . . . . . . . . . . 2
DECAL/LIFT (ns) . . . . . . . . . . . . . . . . . . . 1
9
135275
135376
COVER/CONTROL RIGHT . . . . . . . . . . 1
COVER/CONTROL RIGHT T-BAR . . . . 1
123381
132395
DECAL/TILT (ns) . . . . . . . . . . . . . . . . . . . 1
DECAL/LEFT CONTROL (ns) . . . . . . . . 1
10
30
135283
135276
COVER/CONTROL LEFT . . . . . . . . . . . . 1
PANEL/FRONT . . . . . . . . . . . . . . . . . . . . 1
132396
130297
DECAL/RIGHT CONTROL (ns) . . . . . . . 1
DECAL/HYDRALOC™ (ns) . . . . . . . . . . 1
31
32
135282
135277
PANEL/END . . . . . . . . . . . . . . . . . . . . . . . 1
BLOCK/AIR . . . . . . . . . . . . . . . . . . . . . . . 1
47
48
135382
135399
MAT/FLOOR. . . . . . . . . . . . . . . . . . . . . . . 1
SEAL/SHROUD . . . . . . . . . . . . . . . . . . . . 2
33
34
135278
135279
ASSEMBLY/BODY . . . . . . . . . . . . . . . . . 1
BRACKET/LOUVRE MOUNT. . . . . . . . . 1
49
135378
135774
SEAL/COVER . . . . . . . . . . . . . . . . . . . . . 2
HALF CLAMP/HOSE (ns). . . . . . . . . . . . 2
35
134670
LOUVRE . . . . . . . . . . . . . . . . . . . . . . . . . . 1
650771
BOLT/CARRIAGE 1/4 X 1/2 (ns) . . . . . 2
36
134671
ASSEMBLY/COVER . . . . . . . . . . . . . . . . 1
134588
NUT/SPIRALOCK™ 1/4 (ns) . . . . . . . . . 2
37
134672
MAGNET . . . . . . . . . . . . . . . . . . . . . . . . . . 2
055648
TIE/WIRE (ns) . . . . . . . . . . . . . . . . . . . . . 4
PRINTED IN USA
116
907807/HP1002
nd
Dome Light Kit 807278
re
i
kW
c
Bla
to
ou
Gr
2
3
1
4
132145 Left ROPS Panel
Ref.
No.
Part
No.
REF
807278
KIT/DOME LIGHT . . . . . . . . . . . . . . . . . . 1
1
2
073686
135044
GROMMET . . . . . . . . . . . . . . . . . . . . . . . . 2
HARNESS/DOME . . . . . . . . . . . . . . . . . . 1
3
4
135045
135109
LIGHT/DOME . . . . . . . . . . . . . . . . . . . . . . 1
SCREW/SELF TAPPING #6 X 1/2 . . . . 2
907807/HP1002
Description
Qty.
Req.
117
PRINTED IN USA
Horn Kit 806923
3
1
4
2
Ref.
No.
Part
No.
REF
806923
KIT/HORN. . . . . . . . . . . . . . . . . . . . . . . . . 1
3
127455
WIRE/HORN. . . . . . . . . . . . . . . . . . . . . . . 1
1
2
075104
067785
SWITCH/PUSH BUTTON . . . . . . . . . . . . 1
HORN . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
4
132334
WIRE/HORN . . . . . . . . . . . . . . . . . . . . . . 1
Description
070648
Qty.
Req’d
Ref.
No.
Part
No.
Description
Qty.
Req’d
NUT/HEX FLANGE 5/16 . . . . . . . . . . . 1
Centrifugal Pre-Cleaner Kit 808204
135335
Remove
PRINTED IN USA
118
907807/HP1002
Parker Coupler Kit 807050
4
5
6
7
1
10
3
8
2
9
Ref.
No.
Part
No.
REF
807050
KIT/PARKER COUPLER . . . . . . . . . . . . 1
1
2
048953
055896
O-RING #12 . . . . . . . . . . . . . . . . . . . . . . . 2
O-RING #8 . . . . . . . . . . . . . . . . . . . . . . . . 1
3
4
056104
079417
CAP/DUST . . . . . . . . . . . . . . . . . . . . . . . . 1
CAP/DUST . . . . . . . . . . . . . . . . . . . . . . . . 1
5
6
079418
122864
PLUG/DUST . . . . . . . . . . . . . . . . . . . . . . . 1
COUPLER/MALE SAE12 . . . . . . . . . . . . 1
7
8
122865
128031
COUPLER/FEMALE . . . . . . . . . . . . . . . . 1
COUPLER/MALE . . . . . . . . . . . . . . . . . . . 1
9
10
133096
133098
FITTING/STRAIGHT BULKHEAD . . . . . 1
FITTING/STRAIGHT BULKHEAD . . . . . 2
Description
Engine Auto Shutdown
System Kit 806918
Qty.
Req.
132537
Main Harness
To Fuel Shutoff Solenoid
located at back of Engine
on left side near Battery.
907807/HP1002
119
PRINTED IN USA
Strobe Light Kit 805803
1
3
4
10
9
8
5
7
6
12
2
11
Ref.
No.
Part
No.
Qty.
Req’d
REF
1
805803
088296
KIT/STROBE LIGHT . . . . . . . . . . . . . . . . 1
STROBE . . . . . . . . . . . . . . . . . . . . . . . . . . 1
2
3
088297
073687
TERMINAL/RING . . . . . . . . . . . . . . . . . . . 1
GROMMET . . . . . . . . . . . . . . . . . . . . . . . -1
4
5
071105
078150
CONNECTOR/LINE. . . . . . . . . . . . . . . . . 1
WIRE/BEACON . . . . . . . . . . . . . . . . . . . . 1
6
073200
TERMINAL/MALE BULLET . . . . . . . . . . 1
Description
Ref.
No.
Part.
No.
7
8
078151
055919
CONNECTOR/TAP . . . . . . . . . . . . . . . . . 1
CLIP/WIRE . . . . . . . . . . . . . . . . . . . . . . . . 3
9
10
122483
132274
HARNESS/STROBE . . . . . . . . . . . . . . . . 1
HARNESS/POWER TAP . . . . . . . . . . . . 1
11
12
138310
138313
TERMINAL/INS FEMALE 1/4. . . . . . . . . 1
TERMINAL/INS MALE 1/4 . . . . . . . . . . . 1
5
Description
Qty.
Req’d
7
2
3
Dual Flasher Kit 806920
1
9
14
15
13
Ref.
No.
Part
No.
REF
1
806920
058615
KIT/DUAL FLASHER. . . . . . . . . . . . . . . . 1
CLAMP/INSULATED . . . . . . . . . . . . . . . . 2
2
064145
SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
3
4
075217
075218
5
075219
BRACKET/FLASHER RIGHT. . . . . . . . . 1
BRACKET/FLASHER LEFT
(not shown) . . . . . . . . . . . . . . . . . . . . . . . 1
GUARD/FLASHER RIGHT . . . . . . . . . . . 1
12
650658 NUT/HEX #6 . . . . . . . . . . . . . . . . . . . . . 1
055648
TIES/WIRE (not shown) . . . . . . . . . . . . 24
Description
Qty.
Req’d
Ref.
No.
10
11
Part
No.
055925
089543
651360
654044
Description
Qty.
Req’d
FLASHER (not shown) . . . . . . . . . . . . . . 1
MOUNT/BRACKET FLASHER
(not shown) . . . . . . . . . . . . . . . . . . . . . . . 1
SCREW/MACHINE #6 X 1/4 . . . . . . . . 1
WASHER/LOCK #6 . . . . . . . . . . . . . . . . 1
6
075220
GUARD/FLASHER LEFT (not shown) . 1
13
650577
SCREW/CAP 5/16 X 1-1/2 . . . . . . . . . . . 4
7
087234a
LIGHT/WARNING ASSY . . . . . . . . . . . . 2
14
653007
NUT/HEX 5/16 . . . . . . . . . . . . . . . . . . . . . 4
8
133069
WIRE/FLASHER MAIN (not shown) . . . 1
15
654024
WASHER/LOCK 5/16 . . . . . . . . . . . . . . . 4
9
133070
WIRE/FLASHER DUAL. . . . . . . . . . . . . . 1
a) For replacement Lens order 087247. For replacement
Bulb local purchase #1166 or equivalent.
PRINTED IN USA
120
907807/HP1002
18
4
12
2
23
1
6
5
11
9 10
24
22 819
7
20
14
13
3
21
1
13
15
25
26
16
27
Front Door Kit 807292
17
17
Ref.
No.
Part
No.
REF
1
807292
132713
650487
654004
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
KIT/FRONT DOOR 46/48/56/6635 . . . . 1
ASSY/HINGE . . . . . . . . . . . . . . . . . . . . . . 2
13
14
135455
135456
SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 2
STRIP/TRIM . . . . . . . . . . . . . . . . . . . . . . . 1
SCREW/CAP 5/16 X 1.00 . . . . . . . . . . 4
WASHER/FLAT 5/16 . . . . . . . . . . . . . . 4
15
16
095281
135446
FOAM/EXTENSION. . . . . . . . . . . . . . . . . 2
PLATE/FILLER. . . . . . . . . . . . . . . . . . . . . 1
2
064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4
135437
ASSY/DOOR . . . . . . . . . . . . . . . . . . . . . . 1
3
4
135454
135453
SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1
SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1
17
654009 WASHER/FLAT ½ . . . . . . . . . . . . . . . . 14
129543
FOAM/SEAL . . . . . . . . . . . . . . . . . . . . . . . 3
5
6
132682
132715
GLASS/DOOR . . . . . . . . . . . . . . . . . . . . . 1
WEATHERSTRIP/WINDOW . . . . . . . . . 1
18
19
113839
078200
7
078168
HANDLE/DOOR LATCH . . . . . . . . . . . . . 1
650815 SCREW/MACHINE . . . . . . . . . . . . . . . . 2
650584
650549
8
9
10
12
WASHER/FLAT #10 . . . . . . . . . . . . . . . 2
WASHER/LOCK #10. . . . . . . . . . . . . . . 2
BOLT/CARRIAGE ½ X 1.00 . . . . . . . 14
NUT/HEX ½ . . . . . . . . . . . . . . . . . . . . 14
SEAL/BULB . . . . . . . . . . . . . . . . . . . . . . . 1
MOTOR/DOOR WIPER . . . . . . . . . . . . . 1
650815
650584
SCREW/MACHINE #10 X 3/4 . . . . . . . 1
WASHER/FLAT #10 . . . . . . . . . . . . . . . 6
650549
650550
WASHER/LOCK #10. . . . . . . . . . . . . . . 1
NUT/HEX . . . . . . . . . . . . . . . . . . . . . . . . 1
650550 NUT/HEX MACHINE #10 . . . . . . . . . . 2
095263
COVER/PLATE . . . . . . . . . . . . . . . . . . . . 1
20
21
078248
078249
ARM/ADJUSTABLE. . . . . . . . . . . . . . . . . 1
BLADE. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
078170
BRACKET/LATCH . . . . . . . . . . . . . . . . . . 1
650448 SCREW/CAP1/4 X 3/4 . . . . . . . . . . . . . 2
22
23
114263
055919
WASHER . . . . . . . . . . . . . . . . . . . . . . . . . 2
CLIP/WIRE . . . . . . . . . . . . . . . . . . . . . . . . 3
071401 NUT/LOCK 1/4 . . . . . . . . . . . . . . . . . . . 2
078171
LOCK/CAB . . . . . . . . . . . . . . . . . . . . . . . . 1
24
25
132736
135575
WIRE/WIPER . . . . . . . . . . . . . . . . . . . . . . 1
FILLER/DOOR . . . . . . . . . . . . . . . . . . . . . 1
650548
650549
11
650811
653018
SCREW/MACHINE 10 X ½ . . . . . . . . . 4
WASHER/LOCK #10. . . . . . . . . . . . . . . 4
650811
653018
650550 NUT/HEX MACHINE #10 . . . . . . . . . . 4
136214
PLATE/LOCK . . . . . . . . . . . . . . . . . . . . . . 1
26
654009 WASHER/FLAT ½ . . . . . . . . . . . . . . . . . 8
075308
STRIP/BOLT . . . . . . . . . . . . . . . . . . . . . . 1
650663
SCREW/CAP 1/4 X 5/8 . . . . . . . . . . . . 2
650448
654002
WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 4
071401
071401
NUT/LOCK 1/4 . . . . . . . . . . . . . . . . . . . 2
135435
650510
907807/HP1002
27
BOLT/CARRIAGE ½ X 1.00 . . . . . . . . 4
NUT/HEX ½ . . . . . . . . . . . . . . . . . . . . . 4
080072
SCREW/CAP 1/4 X 3/4 . . . . . . . . . . . . 5
NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 5
FLAP/RUBBER . . . . . . . . . . . . . . . . . . . . 1
FRAME/DOOR . . . . . . . . . . . . . . . . . . . . . 1
SCREW/CAP THREAD CUT 5/16 . . . 6
121
PRINTED IN USA
Airboss Solid Segmented Tire Repair Parts
(To repair tire assemblies: 807425, 807426, 807387, and 807388)
1
Ref.
No.
Part
No.
807425
Description
Qty.
Req’d
Ref.
Part.
No. Description
TIRE ASSEMBLY/RIGHT
807387
807426
TIRE ASSEMBLY/LEFT
REPAIR PARTS:
1
TIRE ASSEMBLY/RIGHT
807388
TIRE ASSEMBLY/LEFT
REPAIR PARTS:
135709
SEGMENT/TIRE . . . . . . . . . . . . . . . . . . . 1
129039 SCREW/HEX HEAD M10 X 30MM . . . 1
071246
656113
Qty.No.
Req’d
1
135658
SEGMENT/ALTRAKKA III . . . . . . . . . . . 1
129038 SCREW/HEX HEAD M8 X 26MM . . . . 1
NUT/NYLON M10-1.5 . . . . . . . . . . . . . . 1
WASHER/FLAT M10. . . . . . . . . . . . . . . 1
071245
656111
NUT/NYLON M8 . . . . . . . . . . . . . . . . . . 1
WASHER/FLAT M8 . . . . . . . . . . . . . . . . 1
Self-Level Valve Kit 807336
10
7
5
8
1
9
6
4
2
3
1
Ref.
No.
Part
No.
Ref.
No.
Part
No.
REF
807336
1
067761
KIT/SELF-LEVEL VALVE . . . . . . . . . . . . 1
6
134831
TUBE/LIFT . . . . . . . . . . . . . . . . . . . . . . . . 1
CONNECTOR/90° . . . . . . . . . . . . . . . . . . 4
7
134832
2
TUBE/TILT . . . . . . . . . . . . . . . . . . . . . . . . 1
135367
VALVE/SELF-LEVEL . . . . . . . . . . . . . . . 1
8
134833
TUBE/TILT REAR . . . . . . . . . . . . . . . . . . 1
3
650733
SCREW/CAP . . . . . . . . . . . . . . . . . . . . . . 2
9
079126
CLAMP/TUBE 0.625” . . . . . . . . . . . . . . . 1
4
131842
NUT/SPIRALOCK . . . . . . . . . . . . . . . . . . 2
10
650784
SCREW/CAP . . . . . . . . . . . . . . . . . . . . . . 1
5
134834
TUBE/SELF-LEVEL. . . . . . . . . . . . . . . . . 1
PRINTED IN USA
Description
Qty.
Req.
122
Description
Qty.
Req.
907807/HP1002
Double Gas Spring Kit 807376
6
2
7
5
8
4
3
3
1
8
3
1
3
7
9
Ref
No.
Part
No.
REF
1
807376
135178
KIT/DOUBLE GAS SPRING. . . . . . . . . . 1
SPRING/GAS . . . . . . . . . . . . . . . . . . . . . . 2
5
6
650448
134588
SCREW/CAP 1/4 X 3/4. . . . . . . . . . . . . . 2
NUT/SPIRALOCK 1/4 . . . . . . . . . . . . . . . 2
2
3
135661
135620
SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
END/ROD . . . . . . . . . . . . . . . . . . . . . . . . . 4
7
8
650725
064260
SCREW/CAP 5/16 X 2-1/4 . . . . . . . . . . . 2
NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . . . 2
4
135186
BRACKET . . . . . . . . . . . . . . . . . . . . . . . . . 1
9
123672
SPACER . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Description
Qty.
Req’d
Ref
No.
Part
No.
Description
Qty.
Req’d
Tilt Cylinder Lock Valve Kit 135564
3
1
2
1
Ref.
No.
Part
No.
REF
135564
KIT/TILT LOCK VALVE . . . . . . . . . . . . . 1
1
112712
CONNECTOR/STRAIGHT . . . . . . . . . . . 4
2
135577
VALVE/LOCK . . . . . . . . . . . . . . . . . . . . . . 1
907807/HP1002
Description
Qty.
Req.
Ref.
No.
3
123
Part
No.
135590
Description
Qty.
Req.
HOSE 1/2 X 42 . . . . . . . . . . . . . . . . . . . . 2
PRINTED IN USA
1
Impact Resistant Front Door Kit 807330
3
5 4
7
6
2
6
5
8
Ref.
No.
Part
No.
REF
1
807330
135435
2
650510 SCREW/CAP THREAD CUT 5/16 . . . 6
135456
STRIP/TRIM . . . . . . . . . . . . . . . . . . . . . . . 1
3
4
132214
133933
650835
654002
Qty.
Req.
Description
Ref.
No.
Part
No.
KIT/IMPACT RESISTANT DOOR . . . . . 1
FRAME/DOOR . . . . . . . . . . . . . . . . . . . . . 1
650487
064260
DOOR/POLYCARBONATE . . . . . . . . . . 1
ASSEMBLY/HINGE . . . . . . . . . . . . . . . . . 1
7
SCREW/CAP 1/4 X 1 . . . . . . . . . . . . . . 4
WASHER/FLAT 1/4. . . . . . . . . . . . . . . . 4
Qty.
Req.
SCREW/CAP 5/16 X 1 . . . . . . . . . . . . . 4
NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4
654004 WASHER/FLAT 5/16 . . . . . . . . . . . . . . 4
130341
HANDLE/DOOR . . . . . . . . . . . . . . . . . . . . 2
6
067040
MAGNET . . . . . . . . . . . . . . . . . . . . . . . . . . 1
651084 SCREW/MACHINE ROUND HEAD . . 2
650550 NUT/HEX #10 X 1 . . . . . . . . . . . . . . . . . 2
135575
FILLER/DOOR . . . . . . . . . . . . . . . . . . . . . 1
8
071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 4
132713
ASSEMBLY/HINGE . . . . . . . . . . . . . . . . . 2
5
Description
650811
654009
BOLT/CARRIAGE 1/2 X 1 . . . . . . . . . . 4
WASHER/FLAT . . . . . . . . . . . . . . . . . . . 8
653018
NUT/HEX 1/2 . . . . . . . . . . . . . . . . . . . . . 4
3
Work Taillight Kit 807293
2
2
Panel Harness
3
1
1
4
4
Engine
Harness
6 8
7 8
6
11
Instrument Panel
5
9
10
8
7 8
6
10
Part
No.
REF
1
807293
122011
KIT/WORK TAILLIGHT . . . . . . . . . . . . . . 1
LIGHT/WORK. . . . . . . . . . . . . . . . . . . . . . 2
6
132285
CLIP/SINGLE . . . . . . . . . . . . . . . . . . . . . . 4
064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 4
2
122847
BRACKET/LIGHT . . . . . . . . . . . . . . . . . . 2
650687 BOLT/CARRIAGE 5/16 X 3/4 . . . . . . . 2
7
132286
CLIP/DOUBLE . . . . . . . . . . . . . . . . . . . . . 2
064260 NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 2
NUT/FLANGED LOCK . . . . . . . . . . . . . 2
8
132048
3
073687
GROMMET . . . . . . . . . . . . . . . . . . . . . . . . 2
9
132047
LAMP/TAIL . . . . . . . . . . . . . . . . . . . . . . . . 2
4
076147
CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 2
10
132046
LAMP/WORK . . . . . . . . . . . . . . . . . . . . . . 2
NUT/LOCK 5/16 . . . . . . . . . . . . . . . . . . 2
11
073036
SWITCH/LIGHT . . . . . . . . . . . . . . . . . . . . 1
5
131941
070648
064260
PRINTED IN USA
Description
Qty.
Req.
Ref.
No.
9
Part
No.
Ref.
No.
Description
Qty.
Req.
BEZEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
HARNESS/REAR GRILLE . . . . . . . . . . . 1
124
907807/HP1002
Deluxe Interior Kit 807429
13
1
14
12
No washer used here
17
18
20
15
19
16
2
3
21
9
8
4
11
6
10
7
5
Ref.
No.
Part
No.
REF
1
807430
132335
132288
651363
2
3
135375
135394
070648
650315
Description
Qty.
Req.
Ref.
No.
KIT/DELUXE INTERIOR 46/4835 . . . . . 1
PAD/SEATBACK . . . . . . . . . . . . . . . . . . . 1
14
SCREW/THREADED 5/16X1.00 . . . . . 6
WASHER/FLAT 3/8 (BLACK) . . . . . . . 5
15
PAD/T-BAR COVER . . . . . . . . . . . . . . . . 1
PAD/LOWER REMOVABLE ROPS . . . . 1
Part
No.
Description
Qty.
Req
132341
COVER/TOOLBOX . . . . . . . . . . . . . . . . . 1
651307 SCREW/PHILLIPS RH 1/4X1/2 . . . . . . 3
071401 NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 3
135362
CONSOLE/LEFT . . . . . . . . . . . . . . . . . . . 1
067750
651308
NUT/SPEED . . . . . . . . . . . . . . . . . . . . . . 6
SCREW/PHILLIPS RH 1/4X3/4 . . . . . . 4
NUT/FLANGED LOCK . . . . . . . . . . . . . 4
SCREW/THREADED 1/4X1/2 . . . . . . . 3
16
132368
SUPPORT/CONSOLE. . . . . . . . . . . . . . . 1
17
650294 SCREW/SELF-TAPPING 1/4X3/8. . . . 3
132348
CONSOLE/RIGHT . . . . . . . . . . . . . . . . . . 1
4
5
135363
135464
PAD/FRONT RIGHT . . . . . . . . . . . . . . . . 1
PAD/FRONT LEFT . . . . . . . . . . . . . . . . . 1
6
7
135366
135463
PAD/RIGHT REAR . . . . . . . . . . . . . . . . . 1
PAD/LEFT REAR . . . . . . . . . . . . . . . . . . . 1
8
9
135572
135573
PAD/CROSSMEMBER . . . . . . . . . . . . . . 1
PAD/CROSSMEMBER . . . . . . . . . . . . . . 1
18
132369
SUPPORT/CONSOLE. . . . . . . . . . . . . . . 1
10
11
135615
135617
PAD/ENGINE COVER . . . . . . . . . . . . . . 1
PAD/GRILLE TO COOLER . . . . . . . . . . 2
19
135361
FOAM/ROPS LEFT . . . . . . . . . . . . . . . . . 1
12
132367
ASSY/TOOLBOX . . . . . . . . . . . . . . . . . . . 1
20
21
132429
135649
FOAM/ROPS RIGHT . . . . . . . . . . . . . . . . 1
PAD/FOAM DONUT . . . . . . . . . . . . . . . . 1
13
132244
650959
067750
651308
NUT/SPEED . . . . . . . . . . . . . . . . . . . . . . 6
SCREW/SELF-TAPPING 1/4X1-1/2 . . 2
093202
DECAL/ELECTRICAL CONTACT (ns) . 1
HINGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
093367
DECAL/WARNING MANUAL (ns) . . . . . 1
651307
093474
DECAL/WARNING GENERAL (ns) . . . . 1
071401
NUT/LOCK 1/4. . . . . . . . . . . . . . . . . . . . 3
907807/HP1002
125
PRINTED IN USA
25
12
24
Side-Mounted Cab Heater Kit 807833
13
16
14
25
16
18
12
7
8
17 19
2
2
22 21
26
23
2
4
20
1
HEATER PARTS ABOVE
9
10
6
9
10
3
5
Ref.
No.
Part
No.
REF
1
807833
055648
KIT/CAB HEATER SIDE MOUNT
TIE/WIRE . . . . . . . . . . . . . . . . . . . . . . . . . 1
14
15
136305
136306
SWITCH/HEATER . . . . . . . . . . . . . . . . . . 1
DECAL/HEATER SWITCH . . . . . . . . . . . 1
2
3
095955
132362
CLAMP/HOSE . . . . . . . . . . . . . . . . . . . . . 4
FITTING/STRAIGHT M18 X 1.50 . . . . . 2
16
17
136307
136308
CORE/HEATER . . . . . . . . . . . . . . . . . . . . 1
FAN MOTOR/HEATER . . . . . . . . . . . . . . 1
4
5
132503
136196
HOSE/LOW PRESSURE 5/8 X 54 . . . . 2
HEATER/SIDE MOUNT . . . . . . . . . . . . . 1
18
19
136309
136310
FAN BLADE/HEATER . . . . . . . . . . . . . . . 1
RESISTOR BLOCK/HEATER . . . . . . . . 1
6
7
136242
136243
SLEEVE/NYLON PROTECTIVE . . . . . . 1
SLEEVE/NYLON PROTECTIVE . . . . . . 1
20
21
136311
136312
RECTIFIER/HEATER . . . . . . . . . . . . . . . 1
FILTER/FRESH AIR . . . . . . . . . . . . . . . . 1
8
9
136292
650448
VALVE ASSEMBLY/BALL . . . . . . . . . . . 1
SCREW/CAP 1/4 X 3/4. . . . . . . . . . . . . . 2
22
23
136313
136314
RETAINER CLIP/FILTER . . . . . . . . . . . . 1
SCREW/THUMB . . . . . . . . . . . . . . . . . . . 2
10
11
654002
136302
WASHER/FLAT 1/4 . . . . . . . . . . . . . . . . . 2
LOUVER/RECTANGULAR . . . . . . . . . . . 1
24
25
136316
136321
SCREW/SEMS. . . . . . . . . . . . . . . . . . . . 29
SCREW #6 X 3/4 . . . . . . . . . . . . . . . . . . . 6
12
13
136303
136304
LOUVER/3” ROUND W/ FLANGE . . . . . 2
KNOB/HEATER SWITCH . . . . . . . . . . . . 1
26
650550
136315
NUT/HEX #10 . . . . . . . . . . . . . . . . . . . . . 1
WIRE HARNESS/HEATER (Not Shown)
PRINTED IN USA
Description
Qty.
Req.
Ref.
No.
126
Part
No.
Description
Qty.
Req.
907807/HP1002
OTHER AVAILABLE ACCESSORIES
Description
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Stock #
Wet Filter Kit (Hydraulic, Oil and Fuel Filters) . . . . . . . . . . . . . . . . . . . . . . . 136232
Cab Enclosure - Vinyl Sides & Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806893
Dirt and Rock Teeth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 807378
Engine Oil Pan Heater - 120 Volt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806835
Replacement Heater Cord, Order through Gehl Parts: Part #133932
Engine Oil Pan Heater - 120 Volt (newer oil pans having a M22 x 1-1/2” threaded port) . . 808203
Replacement Heater Cord, Order through Gehl Parts: Part #133932
Power Cable with Switch for “DX” Model Units - Additional Kit to Power Cold Planer, Rock Wheel
and Stump Grinder, Order through Gehl Parts: Part #129854
Power Cable with Switch Handle for Units Utilizing Palm HD Grader . . . . . . . . . . . 806561
Bolt-On Cutting Edge 63" for RG63 Recycling/Industrial Bucket, Order through Gehl Parts: Part
#131901
Bolt-On Cutting Edge 72" for RG72 Recycling/Industrial Bucket, Order through Gehl Parts: Part
#131902
Bolt-On Cutting Edge Kit for 60" Bucket. . . . . . . . . . . . . . . . . . . . . . . . . . . 133904
Seat Belt - 3" - Where Required by Law . . . . . . . . . . . . . . . . . . . . . . . . . . . 805879
Suspension Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 806829
Attachment All-Tach™ Mount Kit
(Weld-on to convert attachments to All-Tach™ Style) . . . . . . . . . . . . . . . . . . . . 806862
Specify Left or Right Side Mounting on Tire and Wheel Sets when ordering:
•
•
•
•
•
•
•
•
•
•
•
•
•
Tire on Wheel 8.25 x 15 Chevron 6-Ply 1 Only . . . . . . . .
Tire on Wheel 12 x 16.5 Flotation 6-Ply - 1 Only . . . . . . .
Tire on Wheel 12 x 16.5 Galaxy 10-Ply HD - 1 Only . . . . .
Tire on Wheel 33/15.5/16.5 Wide Galaxy 12-Ply HD - 1 Only
Tire on Wheel 14 x 17.5 High Clearance 10-Ply HD- 1 Only .
Tire on Wheel 8.00x 16 Solid - 1 Only . . . . . . . . . . . . .
Tire on Wheel 31.5/13.00/16.5 Galaxy 10-Ply HD - 1 Only . .
Tire on Wheel 10 x 31 Solid Rubber - 1 Only . . . . . . . . .
Tire on Wheel 10 x 33 Solid Rubber - 1 Only . . . . . . . . .
Tire on Wheel 8 x 31 Solid Rubber - 1 Only . . . . . . . . . .
Tire on Wheel 7 x 26 Solid Rubber - 1 Only . . . . . . . . . .
Tire on Wheel 12 x 16.5 Foamfill - 1 Only . . . . . . . . . . .
Tire on Wheel 10 x 16.5 Foamfill - 1 Only . . . . . . . . . . .
907807/HP1002
127
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
805870
805868
806381
806921
806393
805872
807159
807827
807828
807829
807830
808199
808200
PRINTED IN USA
SL46/4835 SKID LOADERS - INDEX
011296
046588
046588
046588
046588
054202
054626
054626
054626
054626
054816
054985
054994
054994
055005
055005
055005
055005
055306
055306
055648
055648
056937
056937
056937
056937
056937
056937
057557
058615
058615
058805
058805
060745
060745
060746
060746
060748
061166
061574
061574
061574
062023
062282
062282
062397
062756
064260
064260
064260
064260
064260
064260
064260
064260
Page Ref.
No.
No.
32
4
4
4
4
38
12
26
28
30
12
70
12
24
10
14
16
18
90
92
70
70
38
40
44
46
48
60
56
34
56
68
70
90
92
90
92
92
8
14
16
18
6
50
52
18
54
14
16
18
32
32
56
66
66
PRINTED IN USA
4
14
15
23
24
5
14
13
13
13
6
5
13
17
5
1
1
1
19
18
1
13
3
25
7
1
9
1
2
9
43
1
9
11
11
12
12
27
23
2
2
2
9
17
9
3
60
9
8
8
1
4
20
8
11
Part
No.
064260
064260
064260
064260
064260
064260
064260
064543
065163
065163
065164
065164
065164
067750
067750
067750
067750
067761
067761
067761
067785
067823
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067847
067888
067950
068034
068034
068034
068034
068034
068938
068938
070634
070634
070634
070648
070648
070648
070648
070648
Page Ref.
No.
No.
66
66
70
72
72
72
72
56
50
52
32
50
52
56
58
58
68
14
16
18
68
56
12
26
26
28
28
28
30
30
30
32
50
50
52
54
54
66
68
60
54
56
56
60
66
12
24
30
66
70
56
56
58
64
72
12
13
3
9
10
11
51
3
12
6
7
9
4
17
25
27
2
4
4
5
3
1
19
11
12
11
12
33
11
12
33
2
1
7
1
4
64
6
4
2
57
3
7
3
1
9
16
42
20
10
8
14
8
7
7
Part
No.
071401
071401
071401
071401
071401
071401
071401
071401
071401
072340
072343
072580
072580
072580
072587
072587
072587
072587
072794
072797
072853
072854
072866
072866
073036
073075
073458
073687
074091
074091
074091
074091
074093
074093
074093
074093
074395
074395
074579
074830
074830
074830
074860
074868
074868
074868
075028
075104
075236
075236
075236
075288
075288
075288
075288
128
Page Ref.
No.
No.
12
36
42
56
58
58
64
64
68
68
2
14
16
18
10
14
16
20
75
75
76
76
40
50
68
75
75
72
6
24
68
70
38
44
46
48
28
30
68
14
16
20
54
34
34
38
70
68
14
28
30
40
44
46
48
10
1
1
9
22
23
10
11
6
7
3
5
5
6
14
40
44
71
2
3
47
48
24
19
8
6
35
8
21
15
9
13
16
21
2
17
33
33
10
41
45
74
7
2
3
11
4
11
6
46
46
23
6
3
3
Part
No.
075722
075722
076058
076147
076147
076147
076147
076147
076147
076588
076588
076879
076880
077685
077794
078723
078730
078734
078912
078914
078919
078931
078942
078945
078946
079029
079029
079039
079039
079092
079092
079092
079097
079098
079098
079098
079098
079098
079098
079126
079126
079126
079126
079126
079126
079152
079157
079209
079209
079209
079209
079209
079213
079213
079216
Page Ref.
No.
No.
84
86
68
6
30
56
66
70
72
10
10
12
12
70
56
60
60
60
8
8
6
8
60
4
4
14
16
38
40
14
16
18
30
14
16
18
26
28
30
14
16
18
26
28
30
4
4
4
4
4
4
54
32
50
44
1
1
12
12
42
44
18
11
9
1
2
20
34
14
12
4
5
6
6
14
8
3
7
9
8
7
6
10
22
8
7
7
6
9
8
8
7
7
7
10
9
9
5
5
5
3
25
14
15
23
24
5
11
10
10
NUMERICAL INDEX
Part
No.
907807/HP1002
NUMERICAL INDEX
Part
No.
079216
079216
079288
079614
080327
080330
080331
080333
080556
080808
080809
080810
080811
080813
081433
082339
083108
087393
087812
087849
087849
087849
087849
087854
087974
088040
088046
088101
088254
088471
088472
088473
088904
088904
088904
088904
088904
088904
088912
088912
088937
089001
089001
089001
089010
089012
089071
089082
089083
089961
090047
091035
091050
091421
091666
907807/HP1002
Page Ref.
No.
No.
46
48
18
32
98
98
98
98
12
100
100
100
100
100
70
6
4
12
4
8
26
28
30
54
32
68
12
54
32
100
100
100
14
16
18
26
28
30
40
50
8
14
16
20
56
56
68
68
68
100
96
75
75
66
70
5
6
10
6
11
6
2
5
39
1
2
3
4
6
7
20
5
11
7
12
17
17
17
6
10
14
38
3
9
7
8
9
11
10
11
22
22
22
21
7
18
39
43
73
14
15
15
16
17
11
6
9
10
15
20
Part
No.
091667
093202
093367
093474
093475
093477
093479
094951
095955
097076
114415
114415
114449
114665
115039
121002
121030
121412
121554
121554
121582
121587
121610
121684
121897
122011
122290
122290
122296
122340
122340
122340
122340
122348
122432
122447
122485
122616
122617
122633
122641
122718
122745
122778
122778
122778
122828
122840
122847
122899
122899
122899
122976
122978
123067
Page Ref.
No.
No.
70
75
75
75
75
75
75
75
8
6
14
16
52
66
32
32
75
56
84
86
60
68
60
12
102
72
75
76
76
14
16
18
24
10
76
70
66
76
76
66
12
75
75
14
16
20
56
102
72
14
16
18
4
4
90
22
11
13
14
15
16
17
24
22
13
14
13
2
5
5
6
34
7
6
5
8
18
9
21
4
6
38
20
52
15
14
14
14
16
20
3
11
18
18
17
7
21
22
38
42
72
11
2
7
16
15
15
25
25
1
129
Part
No.
123067
123069
123069
123070
123070
123073
123073
123079
123079
123080
123080
123084
123084
123087
123093
123094
123110
123110
123114
123122
123122
123123
123123
123129
123380
123381
123383
123501
123554
123722
123722
123722
123817
124078
124078
124089
127342
127349
127349
127349
127360
127360
127428
127455
127488
127488
127488
127488
127488
127488
127556
127623
127629
127669
127679
Page Ref.
No.
No.
92
90
92
90
92
90
92
90
92
90
92
90
92
92
92
90
90
92
92
90
92
90
92
90
76
76
40
66
54
44
46
48
68
50
52
68
2
14
16
18
32
58
8
68
32
34
38
40
50
52
10
34
98
44
90
1
2
2
4
4
7
7
9
9
10
10
17
16
26
29
29
36
34
36
3
3
16
15
27
45
46
20
16
53
15
6
15
11
18
10
19
16
17
16
16
4
33
4
20
8
7
15
19
11
5
15
6
10
11
22
Part
No.
Page Ref.
No.
No.
127679
127717
127963
127989
127989
127990
127990
128007
128007
128015
128105
128105
128106
128106
128108
128108
128112
128130
128130
128166
128166
128316
128316
128316
128316
128316
128316
128316
128507
128591
128738
128979
128984
129004
129055
129055
129063
129063
129066
129130
129132
129258
129301
129310
129314
129314
129314
129314
129326
129363
129385
129419
129420
129706
129706
92
34
68
90
92
90
92
12
70
66
90
92
90
92
90
92
90
90
92
90
92
38
40
44
46
48
50
60
4
2
68
60
60
100
4
4
12
104
100
75
75
75
12
68
14
16
18
102
102
70
70
70
56
18
96
21
3
21
8
8
32
31
40
10
8
5
5
6
6
39
40
18
22
21
21
20
2
18
8
8
8
6
10
25
15
22
11
12
5
1
2
10
10
40
19
41
17
23
18
18
18
3
21
23
24
21
19
PRINTED IN USA
130032
130033
130033
130034
130034
130035
130036
130037
130038
130039
130040
130041
130046
130050
130050
130055
130059
130064
130085
130166
130167
130297
130342
130354
131018
131050
131059
131060
131083
131088
131093
131110
131110
131139
131159
131176
131201
131248
131262
131262
131278
131443
131460
131488
131492
131493
131522
131522
131529
131529
131529
131529
131571
131577
131609
Page Ref.
No.
No.
68
94
96
94
96
96
96
96
96
96
96
96
96
94
96
96
96
68
56
104
104
75
68
68
68
68
10
56
4
34
34
50
52
4
68
54
54
66
50
52
66
54
70
86
12
12
2
106
26
28
90
92
12
14
4
PRINTED IN USA
24
3
12
2
1
9
3
10
11
5
7
4
8
8
13
14
2
25
8
3
1
4
26
50
27
28
1
1
25
13
2
13
7
4
29
5
12
4
8
11
1
9
12
8
5
4
13
3
37
37
28
28
19
19
14
Part
No.
131609
131609
131609
131663
131683
131688
131689
131689
131689
131691
131706
131709
131717
131748
131766
131767
131768
131769
131771
131772
131785
131797
131799
131805
131830
131838
131838
131838
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131842
131863
131892
131913
131940
131941
Page Ref.
No.
No.
4
4
4
4
12
68
26
28
30
56
8
8
66
68
56
56
56
62
30
30
54
66
66
56
2
14
16
18
2
2
6
8
8
10
10
10
16
18
18
20
20
24
32
40
44
46
48
66
68
70
10
4
66
66
72
15
23
24
10
22
30
21
21
21
19
7
8
8
30
4
5
6
1
27
28
8
2
6
10
10
20
19
21
4
24
19
7
19
8
10
11
17
17
26
34
50
13
12
17
9
9
7
9
5
11
1
22
9
3
5
Part
No.
131945
131951
131952
131952
131953
131953
131958
132016
132018
132023
132024
132027
132035
132036
132037
132038
132039
132040
132046
132047
132048
132049
132050
132051
132053
132062
132062
132063
132069
132072
132073
132075
132078
132078
132088
132089
132104
132139
132148
132149
132161
132162
132166
132167
132167
132179
132187
132199
132200
132210
132210
132211
132213
132244
132248
130
Page Ref.
No.
No.
56
8
28
30
28
30
30
76
75
6
6
4
10
10
10
10
10
10
72
72
72
12
2
2
12
26
28
70
34
8
34
34
62
64
54
56
34
75
30
34
58
68
75
62
64
56
76
104
68
22
98
98
20
58
92
18
4
29
29
30
30
39
36
29
17
18
16
8
10
11
8
10
11
1
2
3
29
20
21
28
27
27
13
11
8
12
8
2
2
10
22
1
30
41
10
8
50
33
3
5
20
36
2
31
3
1
66
23
37
Part
No.
132270
132271
132285
132286
132288
132288
132288
132288
132288
132289
132293
132294
132295
132296
132298
132300
132306
132335
132341
132346
132346
132348
132364
132366
132367
132368
132369
132370
132370
132371
132372
132372
132373
132373
132387
132387
132393
132395
132396
132429
132493
132638
132646
132646
132647
132647
132648
132649
132649
132650
132650
132653
132692
132692
132694
Page Ref.
No.
No.
10
10
72
72
56
62
62
64
64
54
66
75
64
64
2
6
66
64
58
36
42
58
68
66
58
58
58
36
42
42
36
42
36
42
36
42
40
76
76
58
66
88
90
92
90
92
92
90
92
90
92
90
22
98
98
3
3
10
11
43
1
3
1
5
8
10
37
10
11
18
15
12
1
24
2
2
27
32
13
22
26
28
3
3
4
4
5
5
6
6
7
16
49
50
31
14
23
23
22
13
13
17
31
30
35
33
26
3
NUMERICAL INDEX
Part
No.
3
907807/HP1002
NUMERICAL INDEX
Part
No.
132695
132989
133030
133064
133074
133557
133957
133966
133966
133970
134060
134201
134219
134230
134241
134241
134243
134286
134299
134327
134327
134331
134345
134356
134368
134368
134368
134368
134371
134372
134398
134398
134400
134400
134400
134426
134427
134436
134436
134436
134437
134437
134437
134447
134455
134455
134455
134456
134456
134456
134464
134464
134474
134474
134483
907807/HP1002
Page Ref.
No.
No.
98
6
64
98
6
6
4
4
88
54
76
2
54
4
40
50
50
92
2
38
44
2
2
54
26
28
30
84
4
4
50
52
44
46
48
2
2
44
46
48
44
46
48
50
26
28
30
26
28
30
28
30
28
30
28
4
16
12
4
11
14
3
1
1
43
1
51
11
15
5
4
7
4
2
1
9
2
10
10
10
25
25
14
8
9
11
7
11
11
16
12
5
17
13
14
15
26
26
26
25
25
25
8
8
9
9
2
Part
No.
134483
134485
134485
134491
134496
134497
134503
134504
134509
134511
134511
134511
134512
134512
134512
134513
134513
134513
134522
134522
134522
134523
134523
134523
134523
134532
134535
134535
134535
134536
134548
134558
134579
134588
134588
134588
134588
134588
134588
134594
134599
134599
134613
134613
134613
134614
134614
134614
134615
134615
134615
134616
134616
134616
134621
Page Ref.
No.
No.
30
28
30
8
30
30
4
4
30
26
28
30
26
28
30
26
28
30
26
28
30
26
28
30
54
44
14
16
18
2
2
2
54
14
16
18
34
36
70
54
18
106
14
16
18
14
16
18
14
16
18
14
16
18
16
2
1
1
1
3
4
19
19
40
14
14
14
16
16
16
15
15
15
12
12
12
11
11
11
4
5
22
22
24
51
51
5
13
18
18
18
8
7
12
52
26
24
24
27
25
25
28
26
26
29
27
27
30
29
131
Part
No.
134621
134622
134622
134642
134643
134645
134647
134648
134649
134658
134658
134658
134659
134659
134659
134681
134681
134685
134691
134694
134696
134696
134696
134697
134697
134697
134698
134698
134702
134702
134702
134707
134709
134710
134724
134728
134729
134748
134749
134756
134757
134760
134774
134775
134776
134777
134792
134792
134792
134792
134793
134793
134793
134794
134794
Page Ref.
No.
No.
18
16
18
8
20
12
12
12
12
44
46
48
44
46
48
56
68
8
8
2
26
28
30
26
28
30
28
30
26
28
30
54
10
10
20
30
30
6
6
2
44
32
20
20
20
20
38
44
46
48
14
16
20
14
16
32
30
33
17
34
16
32
33
12
12
14
10
13
15
11
37
33
1
5
50
36
36
36
34
34
34
31
31
32
32
32
57
7
12
35
37
43
1
1
6
14
12
36
37
38
39
6
4
17
4
30
32
40
31
33
Part
No.
Page Ref.
No.
No.
134794
134814
134822
134824
134827
134827
134830
134830
134830
134831
134831
134832
134832
134833
134833
134834
134834
134837
134839
134840
134841
134841
134842
134843
134844
134847
134848
134849
134851
134851
134851
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134852
134853
134853
134853
20
46
8
2
4
4
14
16
20
16
20
16
20
16
20
16
20
20
84
84
84
86
84
84
84
86
84
86
44
46
48
2
14
16
20
22
24
38
40
44
44
44
44
46
48
48
48
50
52
70
70
70
2
10
12
41
19
2
22
19
19
32
34
42
35
43
36
44
37
45
38
46
47
2
3
4
2
5
9
8
4
7
7
10
20
6
51
39
43
73
2
12
9
14
2
4
18
19
21
4
16
21
14
8
5
16
21
2
4
23
PRINTED IN USA
134853
134853
134853
134853
134853
134853
134855
134855
134855
134856
134856
134856
134857
134857
134858
134858
134865
134866
134874
134878
134878
134878
134879
134880
134888
134889
134914
134923
134924
134925
134926
134927
134938
134939
134940
134941
134964
134965
134966
134966
134966
134966
134966
134966
134966
134966
134969
134970
134971
134972
134973
134977
134980
134983
134983
Page Ref.
No.
No.
12
44
46
48
52
66
26
28
30
26
28
30
28
30
28
30
38
38
54
14
16
94
20
20
44
38
50
14
94
94
94
94
76
76
76
76
76
76
6
6
10
12
12
26
28
30
76
76
76
76
76
68
14
44
46
PRINTED IN USA
25
20
22
18
3
2
23
23
23
24
24
24
34
34
36
36
13
14
54
34
40
49
65
1
1
1
35
4
6
5
1
25
25
25
25
25
25
2
3
4
1
26
19
19
19
25
25
25
25
25
34
36
18
23
Part
No.
134983
134988
134991
135006
135007
135008
135009
135010
135017
135018
135025
135029
135030
135031
135032
135032
135032
135038
135039
135058
135058
135058
135058
135061
135062
135069
135081
135082
135086
135087
135090
135108
135113
135114
135119
135125
135131
135132
135135
135136
135137
135139
135139
135139
135140
135142
135143
135145
135157
135158
135167
135171
135177
135179
135182
Page Ref.
No.
No.
48
20
20
2
20
68
20
70
12
20
10
90
20
20
14
16
18
72
72
26
28
30
86
86
86
48
38
38
8
8
2
10
12
12
10
34
8
8
4
4
40
14
16
18
40
4
4
40
8
40
8
52
56
20
10
16
50
69
51
51
35
52
8
8
53
9
52
68
37
41
20
50
51
18
18
18
0
3
6
2
13
14
2
5
51
2
2
3
2
5
10
9
23
24
13
13
12
13
12
15
14
11
19
11
9
3
13
70
13
Part
No.
135183
135184
135234
135240
135241
135247
135252
135259
135261
135262
135263
135270
135272
135284
135293
135297
135297
135297
135300
135306
135306
135306
135309
135310
135311
135312
135318
135318
135318
135325
135331
135331
135331
135332
135332
135336
135338
135339
135340
135341
135342
135343
135344
135345
135346
135347
135348
135349
135350
135351
135352
135353
135354
135355
135357
132
Page Ref.
No.
No.
10
75
6
56
68
2
56
8
8
8
8
2
12
12
2
14
16
18
54
26
28
30
32
32
4
32
36
42
46
70
14
16
18
46
48
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
88
13
28
19
16
36
50
38
21
27
20
28
7
15
27
14
28
28
31
64
19
19
19
2
1
2
3
8
8
10
6
12
11
12
16
13
1
5
7
8
9
10
11
12
13
15
16
17
18
19
2
3
4
6
14
21
Part
No.
135361
135362
135363
135365
135366
135367
135367
135367
135368
135369
135371
135372
135374
135374
135375
135377
135380
135381
135383
135384
135385
135387
135393
135393
135394
135407
135425
135427
135427
135432
135432
135432
135432
135432
135436
135440
135445
135448
135451
135457
135458
135459
135460
135461
135462
135463
135464
135465
135572
135573
135600
135604
135605
135605
135607
Page Ref.
No.
No.
58
58
64
66
64
16
18
100
98
98
98
8
62
64
64
8
66
66
10
8
10
12
38
44
64
6
6
6
12
12
14
16
18
70
12
12
90
12
12
106
106
106
106
106
106
64
64
4
64
64
66
46
46
48
46
30
25
8
7
13
17
17
8
9
7
25
4
15
6
24
7
19
15
26
17
35
12
3
7
3
7
22
37
10
18
18
18
12
25
25
30
26
23
1
2
4
5
6
7
14
9
25
4
3
20
18
7
12
36
NUMERICAL INDEX
Part
No.
907807/HP1002
NUMERICAL INDEX
Part
No.
135607
135615
135617
135649
135687
135772
135773
135773
135803
135814
135838
135993
135996
136003
136008
136008
136011
136011
136013
136054
136054
136056
136063
136072
136101
136107
136116
136128
136128
136128
136134
136138
136143
136148
136149
136150
136151
136190
136201
136202
136226
136234
136239
136244
136251
136251
136253
136293
136318
136351
136387
136388
136389
136467
136475
907807/HP1002
Page Ref.
No.
No.
48
64
64
64
88
50
12
54
4
2
2
10
36
36
36
42
36
42
2
24
98
6
6
24
12
6
4
62
62
64
40
40
24
24
24
24
24
40
2
2
70
70
52
2
40
50
40
12
98
34
12
92
90
12
50
22
16
19
20
22
16
41
13
12
23
2
4
9
10
11
9
12
10
8
11
6
4
10
36
10
3
1
2
2
10
9
8
7
6
5
4
8
24
25
16
1
1
4
7
2
6
18
4
4
1
24
2
Part
No.
136601
136601
136765
136766
136978
136978
136979
136980
136980
136981
136981
136982
136982
136983
136984
136984
136985
136985
136986
136986
136987
136988
136994
136994
136995
136995
137015
137016
137017
137018
137018
137018
137018
137190
137211
137212
137214
137291
137545
137660
138177
138200
138344
138405
138406
139108
139181
520013
570002
570002
570002
570002
570002
570002
603024
Page Ref.
No.
No.
6
12
54
54
90
92
90
90
92
90
92
90
92
90
90
92
90
92
90
92
90
90
90
92
90
92
92
92
92
10
14
16
20
54
54
54
54
24
75
75
68
88
102
88
88
50
6
4
26
28
30
54
54
86
94
7
24
50
50
5
5
18
21
20
23
22
25
24
26
25
24
20
19
33
32
34
38
24
23
35
33
25
25
17
6
29
31
67
50
56
55
54
9
1
42
13
24
1
25
26
3
2
6
38
38
38
4
11
9
7
133
Part
No.
650225
650225
650294
650294
650315
650387
650387
650394
650394
650426
650433
650449
650449
650449
650453
650453
650453
650453
650453
650453
650453
650453
650483
650484
650484
650485
650486
650486
650486
650486
650486
650487
650487
650487
650488
650490
650490
650490
650490
650490
650490
650490
650490
650490
650490
650490
650490
650491
650491
650491
650491
650491
650491
650491
650491
Page Ref.
No.
No.
36
42
58
58
64
50
52
56
68
70
92
14
16
18
2
2
10
12
12
44
46
48
54
36
42
34
2
8
24
32
54
20
32
70
2
14
16
20
22
24
48
50
52
54
70
70
70
14
16
18
38
40
44
46
50
13
11
26
28
7
12
6
20
7
10
38
18
18
18
10
11
4
1
26
20
24
18
5
14
12
2
24
19
3
12
10
34
1
11
22
39
43
73
1
2
21
14
8
9
5
16
21
34
40
19
10
5
19
25
1
Part
No.
Page Ref.
No.
No.
650491
650492
650492
650492
650492
650494
650494
650495
650495
650495
650495
650499
650533
650533
650533
650533
650533
650535
650535
650535
650535
650542
650542
650545
650545
650545
650547
650547
650547
650547
650549
650549
650549
650549
650549
650550
650551
650551
650551
650551
650551
650551
650551
650552
650554
650568
650568
650568
650568
650568
650568
650568
650573
650573
650573
52
44
46
48
54
2
52
2
12
12
56
56
38
44
44
46
48
26
28
30
92
34
36
26
28
30
26
28
30
30
50
52
52
68
70
68
32
34
34
38
40
50
60
50
4
6
14
16
18
24
28
30
48
66
66
1
18
26
16
64
17
3
2
23
25
7
1
7
2
4
27
4
12
12
12
14
8
15
7
7
7
7
7
7
41
12
2
6
37
1
38
8
6
7
15
4
3
13
3
13
19
9
8
8
1
7
7
7
12
13
PRINTED IN USA
650573
650577
650580
650580
650585
650630
650634
650634
650634
650634
650648
650648
650648
650648
650648
650648
650648
650658
650658
650687
650687
650687
650687
650687
650687
650692
650702
650702
650706
650731
650733
650733
650733
650742
650758
650758
650771
650811
650818
650818
650818
650818
650833
650833
650834
650835
650835
650839
650848
650850
650850
650854
650854
650959
651041
Page Ref.
No.
No.
68
18
36
42
66
58
38
44
46
48
32
50
50
52
52
52
70
56
68
2
44
46
68
72
72
32
2
34
12
90
16
18
20
90
30
70
56
66
26
28
30
54
16
18
66
36
42
36
68
56
56
90
92
58
2
PRINTED IN USA
39
26
16
13
1
8
6
4
29
4
7
9
12
2
4
6
1
20
7
4
9
30
40
7
51
4
20
10
10
14
17
17
50
15
42
12
9
2
11
11
11
4
8
8
2
17
14
18
41
3
11
37
35
22
5
Part
No.
651041
651041
651041
651041
651041
651041
651041
651085
651168
651168
651168
651168
651212
651213
651297
651307
651307
651307
651307
651307
651307
651307
651308
651308
651308
651312
651314
651343
651344
651363
651364
651366
651366
651366
651372
651378
651378
651379
651379
651381
651523
651526
651526
651526
651526
651542
651573
653034
653036
653036
653036
653036
653036
653039
653039
Page Ref.
No.
No.
2
2
2
2
14
16
18
4
54
56
68
70
68
68
54
56
58
58
58
64
64
66
58
58
68
2
68
68
68
64
54
26
28
30
54
6
6
6
12
4
40
4
4
4
4
54
40
66
44
44
44
46
48
38
38
7
9
50
51
20
19
21
1
12
44
42
9
43
44
54
17
23
25
27
10
11
20
25
27
45
8
46
47
48
1
59
19
19
19
13
2
3
7
24
13
2
14
15
23
24
52
3
9
15
16
17
31
6
5
13
Part
No.
653039
653039
654002
654002
654002
654002
654002
654002
654002
654004
654004
654004
654004
654004
654004
654004
654006
654006
654006
654006
654009
654009
654009
654009
654009
654009
654012
654022
654024
654024
654026
654030
654030
654042
654042
654042
654042
654044
654046
654046
655001
655001
655006
656048
656048
656048
656048
656049
656093
656093
656098
656100
656105
134
Page Ref.
No.
No.
38
40
34
44
46
48
50
58
70
32
38
46
50
48
66
70
12
28
30
32
54
56
56
66
66
92
56
52
30
66
54
2
2
68
70
70
70
68
2
58
50
52
56
20
44
46
48
20
6
6
6
70
70
14
1
2
14
35
13
13
22
10
1
7
32
3
4
12
3
19
33
33
2
57
7
11
1
2
39
1
7
41
11
9
10
11
49
4
5
6
7
17
8
11
5
11
63
14
33
13
64
12
19
4
1
4
Part
No.
656110
656110
656141
656149
656149
656188
660080
703692
L62459
L65922
L65928
L99453
L99967
M12070
Page Ref.
No.
No.
6
6
6
50
52
12
2
56
56
75
75
8
8
70
12
19
6
13
7
23
12
22
9
12
51
29
30
10
NUMERICAL INDEX
Part
No.
907807/HP1002
Recommended Coupling & Adapter Installation Torque Specifications
For JIC 37° and 45°
(Machined or Flared)
For SAE “0" Ring Boss (Steel)
Size
Dash
Fractional
(In.)
Minimum
3/16
1/4
5/16
3/8
1/2
5/8
3/4
7/8
1
1-1/4
1-1/2
8
14
18
24
50
72
125
160
200
210
270
-3
-4
-5
-6
-8
-10
-12
-14
-16
-20
-24
907807/HP1002
Steel
Ft-Lbs
Size
Maximum
10
16
20
26
60
80
135
180
220
280
360
135
Ft-Lbs
Dash
Fractional
(In.)
Minimum
Maximum
-4
-5
-6
-8
-10
-12
-16
-20
-24
-32
1/4
5/16
3/8
1/2
5/8
3/4
1
1-1/4
1-1/2
2
10
13
17
34
50
70
94
124
156
219
11
15
19
38
56
78
104
138
173
243
PRINTED IN USA
Torque Specifications
Use these torque values when tightening GEHL hardware (excluding: Lock Nuts, and Self-tapping,
Thread Forming, and Sheet Metal Screws) unless otherwise specified.
Unified
National
Thread
Grade 2
Dry
Grade 5
Lubed
Dry
Grade 8
Lubed
Dry
Lubed
8-32
8-36
10-24
10-32
19*
20*
27*
31*
14*
15*
21*
23*
30*
31*
43*
49*
22*
23*
32*
36*
41*
43*
60*
68*
31*
32*
45*
51*
1/4-20
1/4-28
5/16-18
5/16-24
66*
76*
11
12
50*
56*
9
9
9
10
17
19
75*
86*
13
14
12
14
25
25
9
10
18
20
3/8-16
3/8-24
7/16-14
7/16-20
20
23
32
36
15
17
24
27
30
35
35
40
23
25
35
40
45
50
70
80
35
35
55
60
1/2-13
1/2-20
9/16-12
9/16-18
50
55
70
80
35
40
55
60
75
90
110
120
55
65
80
90
110
120
150
170
80
90
110
130
5/8-11
5/8-18
3/4-10
3/4-16
100
110
175
200
75
85
130
150
150
180
260
300
110
130
200
220
220
240
380
420
170
180
280
320
7/8-9
7/8-14
1-8
1-12
170
180
250
270
125
140
190
210
430
470
640
710
320
360
480
530
600
660
900
1000
460
500
680
740
Metric
Coarse
Thread
Grade 8.8
Dry
Grade 10.9
Lubed
Dry
Lubed
Grade 12.9
Dry
Lubed
M6-1
M8-1.25
M10-1.5
8
19
37.5
6
14
28
11
27
53
8
20
39
13.5
32.5
64
10
24
47
M12-1.75
M14-2
M16-2
65
103.5
158.5
48
76.5
117.5
91.5
145.5
223.5
67.5
108
165.5
111.5
176.5
271
82
131
200
*All Torque Values are in ft-lbs except those marked with an * which are in in-lbs.
For metric torque value (N·m) multiply ft-lbs value by 1.355 or the in-lbs value by 0.113.
®
Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 USA
www.gehl.com
907807/HP1002
© 2002 GEHL COMPANY
All Rights Reserved.
PRINTED IN USA

SL4635/4835 Skid Steer Loaders

Transcription

Similar documents

7600 and 7800 Skid Steer Loaders

3640E/3840E/4240E Parts Manual