Diesel pump unit AQUA-D

We supply water
in any form
MEMBER OF THE SIWATEC GROUP
Mobile pumping station AQUA-D
Mobile pumping stations are suitable for pumping and transportation
of water to irrigation systems or as booster filling stations at irrigation
lines. These aggregates are suitable in operations whereby water must
be pumped without electrical energy supply or on mobile irrigation systems. AQUA-D mobile pumping stations are offered with parameters
ranging from 5 kW to 170 kW. Q/H parameters are about 18 – 900 m3/h,
3.5 – 17.5 bar.
The structure consists of two-wheel underframe with a built-in fuel tank. The
underframe is equipped with stabilization supports and a tow bar, which can
be dismantled. Block of engine and pump is attached to the frame through
silent blocks compensating vibrations caused by operation.
Aggregates contain IVECO, DEUTS or LOMBARDINI engines, and CAPRARI
or ROVATTI pumps. A mobile pumping station also contains appropriate
electronics and safety components.
Basic equipment of the mobile pumping station AQUA-D:
•
•
•
•
•
•
•
3-6 cylinder Diesel engine with air- or water cooling, including
operation liquids
centrifugal pump connected with an engine through a flexible
coupling
two-wheel underframe with a built-in tank
control panel, including complete electro-installation. Panel
is not part of the package for aggregates with lower capacity
(e.g. AQUA-D 20/75)
pressure switch to stop operation in case of pressure drop below
a defined value – serves as protection during piping breakdown
or pump overloading
24-hour timer to set operation time of the aggregate
battery.
Optional equipment of the mobile pumping station AQUA-D:
•
•
•
•
•
•
•
•
•
•
hand-operated membrane pump for filling of the inlet pipe
electric pump for filling of the inlet pipe
inlet and outlet pipe according to client’s requirements,
including fittings
pressure switch to put the aggregate out of operation after
reaching the max. pressure limit
controller of engine revolutions – to control revolutions directly
from the control panel
protective roof above the aggregate machine
anti-noise shielding of the aggregate
remote control of the aggregate using GMS
other automatic components – automatic starter and stopper
of the aggregate due to defined pressures or at breakdown
other modifications of the aggregate, undercarriage, automatics
and other components according to client’s requirement
Parameters of basic types of AQUA-D aggregates
Parameters of basic types of AQUA-D aggregates
Type
Engine
Pump
Lombardini
11LD626/3
Cylinders:
3
AQUA-D
20/75
3
Capacity (cm ):
1870
NEF IVECO
N45MSAA00
Cylinders:
4
Capacity (cm3):
4500
NEF IVECO
N45MSTX20
Cylinders:
4
Capacity (cm3):
4500
NEF IVECO
N67MNTA20
Cylinders:
6
Capacity (cm3):
6700
AQUA-D
40/70
AQUA-D
55/70
AQUA-D
75/75
Type
Rev/min
2600
Dimension
Intake/
discharge
Type of
Frame
Volume (I)
Rovatti
F2R626/2I
42/31
2600
20
75
DN 80/60
S101/50
Rovatti
F34P125KF
81/60
1700
40
71
DN 100/80
SR2/300
Rovatti
F34K125/2I
126/93
1600
54
71
DN
125/100
SR3/360
Rovatti
F34K150/2L 175/129
1700
75
77
DN
150/125
SR4/400
Q (l/s)
H (m)
10
88
15
83
20
75
AQUA 20/75
Type
Rev/min
1800
Q (l/s)
H (m)
30
82
40
80
50
78
30
73
40
71
50
69
Q (l/s)
H (m)
33
110
58
104
83
78
33
98
62
88
75
77
AQUA 40/70
2200
Type
Max.
Parameters
output
Q
H
(HP/kW) Rev/min
Rev/min
1800
10
68
15
63,3
20
51
Q (l/s)
H (m)
30
115
37
112
46
107
AQUA 55/70
1700
Type
Rev/min
1800
AQUA 75/75
1600
23
91
37
86
54
71
1700
Based on demand, Aqua Industrial will deliver mobile pump aggregates with specific parameters directly according
to client’s requirements. Aggregates can be adapted either to pressure applications (up to 17.5 bar) or to capacity
applications (up to 900 m3/hour).
Mobile pumping station AQUA-D
Aqua Industrial s.r.o., Dalimilova 54b, 783 35 Olomouc – Chomoutov
tel.: +420 736 626 696 • web: www.aquaindustrial.cz • email: [email protected]
Data subject to technical modification. Aqua Industrial accepts no liability for damages caused by bad interpretation or use of the information included in this brochure.