Free span hall systems

Free span
hall systems
... for industry and trade ...
www.agrotel.eu
Type of halls
single steel pipe - tunnel (6,2 / 9,2 / 12 m)
I-beam hall (10 / 12 / 15 / 17,5 / 20 / 22 m)
I-beam - tunnel hall (10 / 12 / 15 m)
lattice girder tunnel hall (15 / 18 / 20 / 22 / 25 m)
lattice girder gabled roof hall (25 - 60 (80) m)
Typo of foundations
According to the place of the use, subsoil conditions and static requirements
different kinds of anchorage are possible
strip foundation
pin anchor
-> side view
screw anchor
www.agrotel.eu
nail anchor
ground anchor
Type of facades
Membranefacade
Concrete/
membrane-facade
Sandwich-panelfacade
Advantages of the membrane covering:
•
•
•
•
Wooden facade
planking
hitzeabweisend, neutrale warmth and coldness storage behaviour
very good brightness owing to the light-permeable roof membrane
low noise pollution inside in case of rain, wind and hail
absolute tightness when welded with membrane facade
WellblechFassade
Type of ventilations
whirly bird
shed roof
electrical ridge ventilation
Agrotel membrane ventilation ridge
www.agrotel.eu
Free span ha
I-beam storage hall with adjo
I-beam wood storage hall
wood storage I-beam hall
lattice girder composting tunnel
I-beam logistic
www.agrotel.eu
hall systems
with adjoining office building
lattice girder compost storage hall
with shed roof
lattice girder airplane hangar
lattice girder maintenance hall with inner membrane
am logistic hall
www.agrotel.eu
Tunnel halls
steel storage - I-beam tunnel hall
steel pipe tunnel hall with textile door
steel pipe tunnel halls
I-beam tunnel halls
www.agrotel.eu
Technical informations
Occupancy
Schiebetor
Free span hall systems enable a completely clear effective floor area, for
example storage and logistic halls, vehicle halls, production halls, composting halls, sport halls, agricultural halls.
Foundation
The light weight hall construction you can fasten onto a strip foundation, slab or if applicable with ground anchor plates.
Construction
fixing to the anchor plates onto asphalt
The trusses are designed out of hot dip galvanized square shaped steel
profiles. Influenced by the occupancy, local loads and span widths the
truss heights and profiles can vary.
Roof and facade coverage
The textile membrane consists of an acrylic double PVC laminated
polyester mesh reinforcement of low flammability. The material is UV
stabilized and antistatic. You have the choice beside of the standard
translucent white or every other established RAL colour. The membrane
will be chosen according to the local requirements but at least with a
min. dead weight of 900 g/m2 and a min. tear strength of 4200 N/5 cm
material stripe.
assembly of the steel trusses
Combustion performance
The performance of membrane covered halls is different to the conventional hall systems. The textile material is melting non dripping around
300°C, whereas the melting point of steel can be located between 400
and 500°C. In case of a fire the molten membrane cleared already the
way out for the heat and smoke to ensure a significant lower damage
to the main structure. The membrane conforms to the DIN and ÖNORM
classification B1.
erection of the steel frames
covering of the roof and facade membrane
gable posts
www.agrotel.eu
erection of the gable facade
Advantages in summary
• Competitive system of halls
• Natural illumination through the
translucent membrane
• Flexible occupancy because of the clear
effective floor area
• Slim site schedule for the modular system
• Magnificent free span widths by the
truss system
• Easy and fast removal and reuse
• High resale or recycle value
Your local dealer
AGROTEL GmbH
Gewerbegebiet Hartham 9
D-94152 Neuhaus am Inn
Tel.: +49 (0) 8503 / 914 99-0
Fax: +49 (0) 8503 / 914 99-33
E-Mail: [email protected]
www.agrotel.eu
AGROTEL HandelsGmbH
Goldberg 2
A-4761 Enzenkirchen
Tel.: +43 (0) 7762 / 2777-0
Fax: +43 (0) 7762 / 2777-33
E-Mail: [email protected]