DAV-C770 - Free Service Manuals

Transcription

www.freeservicemanuals.info
11/15/15
DAV-C770/C990
SERVICE MANUAL
US Model
Canadian Model
Ver 1.0 2002.07
DAV-C770/C990
AEP Model
Australian Model
DAV-C770
• DAV-C770/C990 are composed of following models.
As service manuals are issued for each component model, please refer to them.
COMPONENT MODEL NAME
DAV-C770
DAV-C990
SACD/DVD RECEIVER
HCD-C770
HCD-C990
FRONT SPEAKER
SS-TS503
SS-TS551
CENTER SPEAKER
SS-TS503
SS-CT551
REAR SPEAKER
SS-TS503
SS-TS551
SUB WOOFER
SS-WS503
SS-WS551
PACKAGE SPEAKER
SS-WT503
SS-C990
SPECIFICATIONS
PARTS LIST
General
Part No.
Description
1-477-372-11
1-754-060-13
1-754-147-11
1-754-149-11
1-769-108-11
COMMANDER, STANDARD (RM-SS990)
ANTENNA (FM) (C770: AEP, Australian)
ANTENNA (FM) (C770: US, Canadian/C990)
LOOP ANT (AM)
CORD, CONNECTION (VIDEO CORD)
Power requirements
North American model:
European model:
Australian model:
Power consumption
Dimensions (approx.)
Mass (approx.)
Operating temperature
Operating humidity
Supplied accessories
120 V AC, 60 Hz
230 V AC, 50/60 Hz
220 – 240 V AC, 50/60 Hz
135 W (120 V AC) 135 W (230 V AC) (DAV-C770)
140 W (120 V AC) (DAV-C990)
1 W (120 V AC) 2 W (230 V AC) (at the Power Saving Mode)
355 × 70 × 335 mm (14 × 2 7/8 × 13 1/4 inches: DAV-C770)
(14 × 2 7/8 × 15 inches: DAV-C990) (w/h/d) incl. projecting parts
4.4 kg (9 lb 12 oz)
5˚C to 35˚C (41˚F to 95˚F)
5 % to 90 %
• Speakers (5)
• Subwoofer (1)
• AM loop antenna (1)
• FM wire antenna (1)
• Speaker cords (5m × 4, 15m × 2) (17ft. × 4, 50ft. × 2)
• Video cord (1)
• Remote Commander (remote) RM-SS990 (1)
• R6 (size AA) batteries (2)
• Foot pads (20)
• Speakers-connection and Installation (card) (1)
• 21-pin Adapter (1) (Only for the European models)
Design and specifications are subject to change without notice.
Remark
1-824-622-11 CORD (WITH CONNECTOR) (RED)
(for FRONT R SPEAKER)
1-824-622-21 CORD (WITH CONNECTOR) (PURPLE) (for SUB WOOFER)
1-824-622-31 CORD (WITH CONNECTOR) (WHITE)
(for FRONT L SPEAKER)
1-824-622-41 CORD (WITH CONNECTOR) (GRAY)
(for REAR R SPEAKER)
1-824-622-51 CORD (WITH CONNECTOR) (BLUE)
(for REAR L SPEAKER)
1-824-622-61 CORD (WITH CONNECTOR) (GREEN)
(for CENTER SPEAKER)
1-824-180-11
4-241-068-11
4-241-068-21
4-241-068-31
CORD, CONNECTION (21PIN ADAPTER) (AEP)
MANUAL, INSTRUCTION (ENGLISH) (C770)
MANUAL, INSTRUCTION (FRENCH) (C770: Canadian, AEP)
MANUAL, INSTRUCTION (GERMAN, SPANISH, DUTCH,
SWEDISH, ITALIAN, POLISH) (C770: AEP)
4-241-068-41 MANUAL, INSTRUCTION (DANISH, FINNISH,
PORTUGUESE) (C770: AEP)
4-241-068-51
4-241-071-11
4-241-071-21
4-243-416-01
4-243-457-01
MANUAL, INSTRUCTION (GREEK) (C770: AEP)
MANUAL, INSTRUCTION (ENGLISH) (C990)
MANUAL, INSTRUCTION (FRENCH) (C990: Canadian)
BATTERY COVER (for RM-SS990)
RUBBER (SPEAKER) (for SPEAKER)
COMPACT AV SYSTEM
9-874-058-01
Sony Corporation
2002G0500-1
C 2002.07
Home Audio Company
Published by Sony Engineering Corporation.
Published in Heiloo, Holland.
www.freeservicemanuals.info
11/15/15
DAV-C770/C990
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
2
Date
2002.07
Description of Revision
New
Published in Heiloo, Holland.
HCD-C770/C990
SERVICE MANUAL
US Model
Canadian Model
Ver 1.5 2003.07
HCD-C770/C990
AEP Model
Australian Model
HCD-C770
HCD-C770/C990 is the amplifier, DVD/CD
player and tuner section in DAV-C770/C990.
Photo: HCD-C770
Model Name Using Similar Mechanism
NEW
Mechanism Type
CDM69-DVBU16
Base Unit Name
DVBU16
Optical Traverse Unit Name
DBU-1
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (C770: US model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 3 ohm loads, both channels driven, from 150 – 10,000 Hz; rated
70 watts per channel minimum RMS power, with no more than 1 %
total harmonic distortion from 250 milliwatts to rated output.
AUDIO POWER SPECIFICATIONS (C990: US model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 3 ohm loads, both channels driven, from 150 – 10,000 Hz; rated
75 watts per channel minimum RMS power, with no more than 1 %
total harmonic distortion from 250 milliwatts to rated output.
Amplifier section
Stereo mode (C770)
Stereo mode (C990)
Surround mode (C770)
90 W + 90 W (3 ohms at 1 kHz, THD 10 %)
100 W + 100 W (3 ohms at 1 kHz, THD 10 %)
Front: 90 W + 90 W
Center*: 90 W
Rear*: 90 W + 90 W (3 ohms at 1 kHz, THD 10 %)
Subwoofer*: 100 W (3 ohms at 100 Hz, THD 10 %)
Surround mode (C990)
Front: 100 W + 100 W
Center*: 100 W
Rear*: 100 W + 100 W (3 ohms at 1 kHz, THD 10 %)
Subwoofer*: 100 W (3 ohms at 100 Hz, THD 10 %)
* Depending on the sound field settings and the source, there may be no sound output.
Inputs (Analog)
Inputs (Digital)
Outputs (Analog)
VIDEO 1, 2:
Sensitivity: 150 mV
Impedance: 50 kilohms
VIDEO 2 (optical):
Sensitivity: –
VIDEO 1 (AUDIO OUT):
Voltage: 2 V
Impedance: 1 kilohms
PHONES:
Accepts low- and high-impedance headphones
– Continued on next page –
SACD/DVD RECEIVER
9-874-059-06
Sony Corporation
2003G05-1
C 2003.07
Home Audio Company
Published by Sony Engineering Corporation
HCD-C770/C990
SELF DIAGNOSIS FUNCTION
Super Audio CD/DVD system
Laser
Semiconductor laser
(Super Audio CD/DVD: λ = 650 nm)
(CD: λ = 780 nm)
Emission duration: continuous
Signal format system
NTSC or NTSC/PAL
Frequency response (at 2 CH STEREO mode)
DVD (PCM): 2 Hz to 22 kHz (±1.0 dB)
CD: 2 Hz to 20 kHz (±1.0 dB)
Signal-to-noise ratio
More than 80 dB (VIDEO 1 (AUDIO) connectors only)
Harmonic distortion
Less than 0.03 %
FM tuner section
System
Tuning range
Other models:
Antenna
Antenna terminals
Intermediate frequency
PLL quartz-locked digital synthesizer system
87.5 – 108.0 MHz (100 kHz step)
87.5 – 108.0 MHz (50 kHz step)
FM wire antenna
75 ohms, unbalanced
10.7 MHz
Self-diagnosis Function
(When letters/numbers appear in the
display)
When the self-diagnosis function is
activated to prevent the system from
malfunctioning. In this case a five-character
service number (e.g., C 13 00) with a
combination of a letter and digits appears on
the screen and the front panel display. Refer
to the following table.
AM tuner section
System
Tuning range
European model:
Other models:
Antenna
Intermediate frequency
530 – 1,710 kHz (with the interval set at 10 kHz)
Loop antenna
450 kHz
Video section
Inputs
Outputs
C:13:00
PLL quartz-locked digital synthesizer system
Video: 1 Vp-p 75 ohms
Video: 1 Vp-p 75 ohms
S video:
Y: 1 Vp-p 75 ohms
C: 0.286 Vp-p 75 ohms
COMPONENT:
Y: 1 Vp-p 75 ohms
PB/CB, PR/CR: 0.7 Vp-p 75 ohms
First three
characters of
the service
number
C 13
C 31
General
Power requirements
European model:
Australian model:
Power consumption (C770)
Power consumption (C990)
Dimensions (approx.)
Mass (approx.)
Operating temperature
Operating humidity
120 V AC, 60 Hz
230 V AC, 50/60 Hz
220 – 240 V AC, 50/60 Hz
135 W (120 V AC) 135 W (230 V AC)
1 W (120 V AC) 2 W (230 V AC)
(at the Power Saving Mode)
140 W (120 V AC)
1 W (120 V AC) (at the Power Saving Mode)
355 × 70 × 335 mm (14 × 2 7/8 × 13 1/4 inches) (w/h/d)
incl. projecting parts
4.4 kg (9 lb 12 oz)
5˚C to 35˚C (41˚F to 95˚F)
5 % to 90 %
E XX
(xx is a number)
Cause and/or Corrective
Action
The disc is dirty.
, Clean the disc with a soft
cloth.
The disc is not inserted
correctly.
, Re-insert the disc
correctly.
To prevent a malfunction, the
system has performed the selfdiagnosis function.
, Contact your nearest Sony
dealer or local authorized
Sony service facility and
give the 5-character
service number.
Example: E 61 10
Design and specifications are subject to change without notice.
Note: Refer to the “5. TEST MODE” (page 22) for another self-diagnosis
function.
2
HCD-C770/C990
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs,
screws, and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale.
The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2 V AC range are suitable. (See Fig. A)
To Exposed Metal
Parts on Set
This appliance is classified as a
CLASS 1 LASER product. The label
is located on the bottom exterior.
0.15 µF
1.5 kΩ
AC
voltmeter
(0.75 V)
Earth Ground
This label is located on the bottom
exterior.
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0
SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE
DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ
DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES
NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
3
HCD-C770/C990
Ver 1.5
TABLE OF CONTENTS
SELF DIAGNOSIS FUNCTION ....................................
2
1.
SERVICING NOTES ...............................................
5
2.
GENERAL
Location of Controls ......................................................
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
3-15.
3-16.
3-17.
3-18.
3-19.
Disassembly Flow ..........................................................
Front Panel (AL) Section, Side Panel (L)/(R) ...............
Mechanism Deck (CDM69-DVBU16) ..........................
POWER SW Board ........................................................
AUDIO Board, VIDEO Board .......................................
AMP Board ....................................................................
POWER Board ...............................................................
DVD Board .....................................................................
Optical Pick-up (DVBU16) ...........................................
Pick-up Unit (TDP022W) ..............................................
SW Board, Bracket (Top) assy ......................................
RELAY Board ................................................................
Motor (Stocker) Assy (Stocker) (M781) .......................
Motor (Stocker) Assy (Roller) (M771) .........................
Motor (Stocker) Assy (Mode) (M761) ..........................
Rubber Roller (Slider) Assy ..........................................
Timing Belt (Front/Rear) ...............................................
Cam (Gear) .....................................................................
SENSOR Board ..............................................................
4.
ASSEMBLY
4-1.
4-2.
4-3.
4-4.
4-5.
How to Install the Cam (Eject Lock) .............................
How to Install the Cam (Gear) .......................................
How to Install the Gear (Mode 2) ..................................
How to Install the Gear (Mode Cam) ............................
How to Install the Rotary Encoder (S702),
Gear (Stocker Communication) .....................................
4-6. How to Install the Cam (Stocker U/D) ..........................
4-7. How to Install the Stocker Assy .....................................
4-8. Phase Adjustment Between Pinions (Slider)
And Slider-1 to 5 (L/R) ..................................................
6
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
18
18
19
19
20
20
21
21
22
23
5.
TEST MODE ............................................................. 24
6.
ELECTRICAL ADJUSTMENT ........................... 31
7.
DIAGRAMS
7-1.
7-2.
7-3.
7-4.
7-5.
Block Diagram – RF SERVO Section – .......................
Block Diagram – AUDIO (DSP) Section – ..................
Block Diagram – AUDIO OUT, PANEL Section – .....
Block Diagram – VIDEO Section – .............................
Block Diagram
– CHANGER, POWER SUPPLY Section – .................
Note for Printed Wiring Boards and
Schematic Diagrams ......................................................
Printed Wiring Boards – RF Section – .........................
Schematic Diagram – RF Section – ..............................
Printed Wiring Boards – CHANGER Section – ...........
Schematic Diagram – CHANGER Section – ...............
Printed Wiring Board
– DVD Board (Component Side) – ...............................
Printed Wiring Board
– DVD Board (Conductor Side) – .................................
Schematic Diagram – DVD Board (1/10) – .................
7-6.
7-7.
7-8.
7-9.
7-10.
7-11.
7-12.
7-13.
7-14.
7-15.
4
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
7-16.
7-17.
7-18.
7-19.
7-20.
7-21.
7-22.
7-23.
7-24.
7-25.
7-26.
7-27.
7-28.
7-29.
7-30.
7-31.
7-33.
7-34.
7-35.
7-36.
7-37.
7-38.
7-39.
7-40.
Schematic Diagram – DVD Board (10/10) – ...............
Printed Wiring Board – AMP Section (1/2) – ..............
Printed Wiring Boards – AMP Section (2/2) – .............
Schematic Diagram – AMP Section (1/2) – .................
Schematic Diagram – AMP Section (2/2) – .................
Printed Wiring Boards – AUDIO Section – .................
Schematic Diagram – AUDIO Section – ......................
Printed Wiring Board – VIDEO Section – ...................
Schematic Diagram – VIDEO Section – ......................
Printed Wiring Boards
– DC-DC CONVERTER Section – ...............................
Schematic Diagram
– DC-DC CONVERTER Section – ...............................
Printed Wiring Boards – CONTROL Section – ...........
Schematic Diagram – CONTROL Section – ................
Printed Wiring Board – FL Board – .............................
Schematic Diagram – FL Board – ................................
Printed Wiring Boards – POWER Section (1/2) – .......
Printed Wiring Boards – POWER Section (2/2) – .......
Schematic Diagram – POWER Section – ....................
IC Pin Function Description ..........................................
8.
EXPLODED VIEWS
8-1.
8-2.
8-3.
8-4.
8-5.
8-6.
8-7.
8-8.
8-9.
8-10.
8-11.
8-12.
8-13.
General Section .............................................................
Front Panel Section-1 ....................................................
Front Panel Section-2 ....................................................
Chassis Section-1 ..........................................................
Chassis Section-2 ..........................................................
Chassis Section-3 ..........................................................
Mechanism Deck Section-1 (CDM69-DVBU16) ........
Optical Pick-up Section (DVBU16) .............................
9.
ELECTRICAL PARTS LIST ............................. 120
7-32.
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
88
107
108
109
110
111
112
113
114
115
116
117
118
119
HCD-C770/C990
Ver 1.3
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
JIG ON REPAIRING
When repairing this set, etc., connect the extension cable as the
figure shown below.
extension cable
(relay board-DVD board)
(Part No. J-2501-143-A)
RELEASING THE DISC SLOT LOCK
The disc slot lock function for the antitheft of an demonstration
disc in the store is equipped.
Releasing Procedure:
1. Press two buttons of [DISC 1] and x simultaneously for five
seconds.
2. The message “UNLOCKED” is displayed and the slot is unlocked.
Note: When “LOCKED” is displayed, the slot lock is not released by
turning power on/off with the [POWER] button.
CHECKING OF OPERATIONS WITH REMOTE
COMMANDERS OF DIFFERENT MODELS
Some of the signal of remote commander vary between generation
of player.
Between DAV-S400/S500/S800/C450/C700/C900 and DAV-S550/
S880/C770/C900, remote commander signal codes of
“FUNCTION”, “BAND”, “ST/MONO” and “MEMORY” are
different.
Take notice of the above when you check the operation with remote
commanders of different models.
extension cable
(DVD board-AMP board)
(Part No. J-2501-198-A)
extension cable
(DVD board-AMP board)
(Part No. J-8000-024-A)
extension cable
(RF board-DVD board)
(Part No. J-2501-217-A)
5
HCD-C770/C990
SECTION 2
GENERAL
This section is extracted from
instruction manual.
LOCATION OF CONTROLS
Front Panel
STANDBY
FUNCTION
1 POWER switch
2 STANDBY indicator
3 DISC 1 (play) /A (Eject)/indicator –
DISC 5 (play) /A (Eject)/indicator
4 H (play)
5 X (pause)
6 x (stop)
7 ./> PREV/NEXT, PRESET –/+
8 PHONES jack
9
0
qa
qs
qd
qf
qg
qh
BAND
DISPLAY
SOUND FIELD
PHONES
VOLUME control
SOUND FIELD –/+
DISPLAY
BAND
FUNCTION
Disc slot
Front panel display
(remote sensor)
Rear Panel
COMPONENT
VIDEO OUT
FRONT
L
FRONT
R
CENTER
WOOFER
IMPEDANCE
USE
R E A R WOOFER 3Ω
L
EXCEPT
WOOFER 3Ω
REAR
R
SPEAKER
VIDEO 1
AM
R
AUDIO OUT
L
AUDIO IN
L
R
MONITOR
OUT
SCAN SELECT
VIDEO 2
VIDEO OUT
VIDEO
VIDEO IN
S VIDEO
SELECTABLE
INTERLACE
COAXIAL
DVD
ONLY
OPTICAL
DIGITAL
IN
FM
75Ω
R
L
AUDIO IN
VIDEO IN
Y
P B/CB
PR/CR
VIDEO 2
COMPONENT VIDEO OUT
1
2
3
4
5
6
SPEAKER jacks
AM antenna
VIDEO 1 jacks
VIDEO 2 jacks
COMPONENT VIDEO OUT/SCAN
SELECT switch
6 MONITOR OUT (VIDEO/S VIDEO)
jacks
7 VIDEO 2 (OPTICAL DIGITAL IN)
jack
8 COMPONENT VIDEO OUT jacks
9 FM 75Ω COAXIAL antenna jack
HCD-C770/C990
Front Panel Display
When playing back a DVD
Current sound
Playing status
PCM
DIGITAL
PRO LOGIC
ALL 1 DISC S
TITLE
Play mode
Lights up when you can
change the angle
Current chapter number
CHAPTER
H
Current title number
M
S
Playing time
ANGLE
REPEAT 1
Current repeat
mode
Current surround format
When playing back a Super Audio CD, CD, VIDEO CD, or MP3
Current index number
(The index indicator does not appear during Super
Audio CD or MP3 playback.)
Current sound
TRACK
PCM
SACD
DIGITAL
INDEX
M
Lights up during
PBC playback
(VIDEO CD only)
S
REPEAT 1
PROG PBC
SHUFFLE
ALL 1 DISC S
Play mode
Current track number
Playing time
Current play mode
Playing status
When listening to the radio
Preset number
Monaural/Stereo effect
TUNED
MONO ST
FM AM
MHz
Current band
Current station
7
HCD-C770/C990
Remote
1
2
3
4
5
6
7
8
9
>10
10/0
Note
This remote control glows in the dark. However,
before glowing, the remote must be exposed to light
for awhile.
8
1
2
3
4
5
6
TV [/1 (on/standby)
Z (EJECT)
NAME
STEREO/MONO
MEMORY
CLEAR
7
8
9
q;
qa
qs
PLAY MODE
AUDIO
ANGLE
SUBTITLE
VOL +/–
./> PREV/NEXT, TV CH –/+,
PRESET –/+
qd
qf
qg
qh
qj
qk
H PLAY/SELECT
DVD TOP MENU
DVD DISPLAY
C/X/x/c/ENTER
DVD SETUP
1 (standby)
ql
w;
wa
ws
wd
wf
DISC SKIP
TV/VIDEO
REPEAT
MUTING
TIME
FUNCTION
wg
wh
wj
wk
wl
e;
BAND
Number buttons
SOUND FIELD
DISPLAY
ENTER
COMMAND MODE DVD TV switch
ea
es
ed
ef
eg
eh
m/M/ /
x STOP
X PAUSE
DVD MENU
O RETURN
AMP MENU
SLOW, TUNING –/+
HCD-C770/C990
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1.
DISASSEMBLY FLOW
SET
3-2. FRONT PANEL (AL)
SECTION,
SIDE PANEL (L)/(R)
(Page 10)
3-3. MECHANISM DECK
(CDM69-DVBU16)
(Page 10)
3-7. POWER BOARD
(Page 12)
3-6. AMP BOARD
(Page 12)
3-8. DVD BOARD
(Page 13)
3-11. SW BOARD,
BRACKET (TOP)
ASSY (Page 14)
3-9. OPTICAL PICK-UP
(DVBU16) (Page 13)
3-4. POWER SW
BOARD
(Page 11)
3-10. PICK-UP UNIT
(TDP022W)
(Page 14)
3-5. AUDIO BOARD,
VIDEO BOARD
(Page 11)
3-16. RUBBER ROLLER
(SLIDER) ASSY
(Page 17)
3-15. MOTOR (STOCKER)
ASSY (MODE)
(M761) (Page 16)
3-17. TIMING BELT
(FRONT/REAR)
(Page 17)
3-18. CAM (GEAR)
(Page 18)
ASSY (STOCKER)
(M781) (Page 15)
3-12. RELAY BOARD
(Page 15)
ASSY (ROLLER)
(M771) (Page 16)
3-19. SENSOR BOARD
(Page 18)
9
HCD-C770/C990
Note: Follow the disassembly procedure in the numerical order given.
3-2.
FRONT PANEL (AL) SECTION, SIDE PANEL (L)/(R)
7 front panel (AL)
section
6 connector
(CN807)
4 wire (flat type) (CN814)
8 two screws
(BVTP3 × 8)
5 connector (CN900)
9 side panel (L)
3
1 three screws
(BVTP3 × 8)
0 two screws
(BVTP3 × 8)
2 three screws
(BVTP3 × 8)
qa side panel (R)
3-3.
MECHANISM DECK (CDM69-DVBU16)
1 four screws
(BVTP3 × 8)
4 wire (flat type)
(CN002)
5 mechanism deck
(CDM69-DVBU16)
3 wire (flat type)
(CN701)
2
10
HCD-C770/C990
3-4.
POWER SW BOARD
4 two screws
(BVTP3 × 8)
7 four screws
(BTP3 × 6)
9 power button
section
5 connector
(CN900)
1 screw
(BVTP3 × 8)
2 SEL board
0 power SW board
6 connector
(CN901)
8 MD cover sub assy
3 two screws
(BVTP3 × 8)
3-5.
AUDIO BOARD, VIDEO BOARD
6 connector
(CN205)
5 wire (flat type)
(CN208)
4 wire (flat type)
(CN202)
3 wire (flat type)
(CN201)
8 audio board
2 FM/AM tuner pack (DTP-001)
9 wire (flat type)
(CN203)
0 two screws
(BVTP3 × 8)
7 four screws
(BVTP3 × 8)
qa video board
1 two screws
(BVTP2.6 × 8)
11
HCD-C770/C990
3-6.
AMP BOARD
6 connector
(CN302)
5 wire (flat type)
(CN301)
1 four screws
(BVTP3 × 8)
4 wire (flat type)
(CN305)
8 AMP board
3
2 two screws
(BVTP3 × 8)
7 connector
(CN904)
3-7.
POWER BOARD
2 connector
(CN903)
3 connector
(CN902)
1 connector
(CN904)
4 four screws
(BVTP3 × 8)
7 power board
6 power sheet
5
12
HCD-C770/C990
3-8.
DVD BOARD
3
1 two screws
(BVTP3 × 8)
2 two screws
(BVTP3 × 8)
4 wire (flat type)
(CN006)
8 two screws
(BVTP3 × 8)
5 wire (flat type)
(CN002)
9 DVD board
6 wire (flat type)
(CN003)
7 wire (flat type)
(CN401)
3-9.
OPTICAL PICK-UP (DVBU16)
2
3 boss
1 screw
(PTPWHM2.6)
5 boss
4 boss
6 optical pick-up
(DVBU16)
13
HCD-C770/C990
3-10. PICK-UP UNIT (TDP022W)
1 step screw (M)
2 step screw (M)
7 insulator
4
0 pick-up unit (TDP022W)
8 insulator
3 step screw (M)
9 insulator
6 flexible board
5 connector
(CN003)
holder (DBU1) section
3-11. SW BOARD, BRACKET (TOP) ASSY
4 SW board (3)
3 SW board (2)
1 four screws
(BTP2.6 × 6)
2 SW board (1)
7 bracket (top) assy
14
5 SW board (4)
6 six screws
(BVTP2.6 × 8)
HCD-C770/C990
3-12. RELAY BOARD
0 relay board
3
– bottom view –
9 connector
(CN708)
relay board
8 connector
(CN707)
4 connector
(CN703)
1 Remove five solders.
5 connector
(CN702)
2 four screws
(BVTP2.6 × 8)
7 connector
(CN706)
6 connector
(CN710)
3-13. MOTOR (STOCKER) ASSY (STOCKER) (M781)
3 two screws
(BVTP2.6 × 8)
4
2 Remove two solders
6 stocker motor board
5 connector
(CN761)
7 motor (stocker) assy
(stocker) (M781)
1 belt (stocker)
15
HCD-C770/C990
3-14. MOTOR (STOCKER) ASSY (ROLLER) (M771)
3 two screws
(BVTP2.6 × 8)
2 Remove two solders.
4 roller motor board
(roller) (M771)
1 belt (roller)
3-15. MOTOR (STOCKER) ASSY (MODE) (M761)
1 Remove five solders
of rotary encoder.
3 two screws
(BVTP2.6 × 8)
4 mode motor board
(mode) (M761)
mode motor
board
2 Remove two solders
of motor (M761)
5 belt (mode)
16
HCD-C770/C990
3-16. RUBBER ROLLER (SLIDER) ASSY
8 step screw
0 rubber roller
(slider 4) assy
5 step screw
9 tension
spring
(slider 2)
1 step screw
6 tension spring
(base slider 5)
2 rubber roller
(slider S) assy
qa rubber roller
(slider 2) assy
3 tension spring
(base slider 5)
qs step screw
7 rubber roller
(slider 1) assy
qd rubber roller
(slider 1) assy
qf screw
(BVTP2.6 × 8)
4 rubber roller
(slider 5) assy
qg sub chassis
3-17. TIMING BELT (FRONT/REAR)
3 slider (mode cam) assy
7 two gears (center)
When install three timing belts,
its pass under each claws.
8 timing belt (rear)
timing belt
(rear)
5 two gears
(center)
9 timing belt (rear)
claw
6 timing belt
(front)
timing belt
(rear)
claw
claw
claw
4 gear
(timing)
timing belt (front)
2 gear (mode cam)
: Note
1 screw
(PTPWH2.6 × 8)
Note: Refer to assembly (Section 4)
17
HCD-C770/C990
3-18. CAM (GEAR)
6 gear (mode 4)
5 screw
(PTPWH2.6 × 8)
qs cam (gear)
: Note
4 gear
(mode 5)
3 screw
(PTPWH2.6 × 8)
0 gear
(mode 2)
:Note
2 pulley
(mode deceleration)
qa screw
(PTPWH2.6 × 8)
9 screw
(PTPWH2.6 × 8)
1 screw
(PTPWH2.6 × 8)
8 gear (mode 3)
7 screw
(PTPWH2.6 × 8)
Note: Refer to assembly (Section 4).
3-19. SENSOR BOARD
Note: Refer to assembly (Section 4).
qk harness
qj claw
9 cam
(eject lock)
: Note
8 screw
(PTPWH2.6 × 8)
qs gear
(eject lock)
qg two claws
qa cam
(BU U/D)
w; sensor board
7 shaft
(shutter)
6 compression spring
(shutter)
qh rotary encoder
(S701)
qd gear
(mode 1)
ql screw
(BVTP2.6 × 8)
qf screw
(PTPWH2.6 × 8)
5 base (shutter) block
3 screw
(BVTP2.6 × 8)
0 screw
(PTPWH2.6 × 8)
1 screw
(PTPWH2.6 × 8)
18
4 two screws
(BVTP2.6 × 8)
2 lever shutter (A)
HCD-C770/C990
SECTION 4
ASSEMBLY
Ver 1.5
• This set can be assembled in the order shown below.
4-1.
HOW TO INSTALL THE CAM (EJECT LOCK)
1 Rotate the cam (BU U/D) fully in the direction of arrow.
2 Engage the gear (eject lock) and the gear of the cam (eject lock)
aligning the mark with the center of the gear (eject lock).
cam (BU U/D)
mark
gear (eject lock)
cam (eject lock)
– bottom view • front –
4-2.
HOW TO INSTALL THE CAM (GEAR)
1 Check that the cam (BU U/D) can not be rotated in the direction of arrow.
2 Align the mark on the cam (gear) with the boss as shown in the figure
and install the cam (gear).
cam (gear)
boss
cam (BU U/D)
mark
19
HCD-C770/C990
Ver 1.5
4-3.
HOW TO INSTALL THE GEAR (MODE 2)
1 Align the mark on the rotary encoder (S701) with the projection of the assy.
2 Check that the cam (BU U/D) can not be rotated in the direction of arrow.
3 Install the gear (mode 2).
rotary encoder
(S701)
cam (BU U/D)
gear
(mode 2)
mark
projection
chassis
4-4.
HOW TO INSTALL THE GEAR (MODE CAM)
1 Slide the shaft in the direction of arrow.
2 Align mark A on the gear (mode cam) with mark B on the slider (mode cam) assy,
then install the gear (mode cam).
3 Check that mark C on the gear (mode cam) is in alignment with mark D on the cam (gear).
shaft
mark A
gear (mode cam)
mark D
slider (mode cam) assy
mark B
mark C
cam (gear)
20
HCD-C770/C990
Ver 1.5
4-5.
HOW TO INSTALL THE ROTARY ENCODER (S702), GEAR (STOCKER COMMUNICATION)
4 gear
(stocker communication)
5 screw
(PTPWH2.6 × 8)
3 screw
(PWH2 × 6)
Engage the rotary encoder (S702)
and the gear (stocker communication)
as shown below in the figure.
7 two screws
(PTPWH2.6 × 8)
1 rotary encoder
(S702)
6 two gears
rotary encoder
(S702)
2 five solders
gear
(stocker
communication)
relay board
– rear –
4-6.
HOW TO INSTALL THE CAM (STOCKER U/D)
1 Position the hole on the gear
(stocker communication) on the
screw of the rotary encoder (S702).
rotary encoder
(S702)
hole
screw
gear
– rear –
3 screw
(PTPWH2.6 × 8)
3 two screws
(PTPWH2.6 × 8)
2 cam (stocker U/D)
cam (stocker U/D)
f mark
cam (stocker U/D)
f mark
2 two cams
(stocker U/D)
f mark
cam (stocker U/D)
To install three cams (stocker U/D), align each groove
of the cam (stocker U/D) with each f mark on the
chassis as shown in the figure.
21
HCD-C770/C990
Ver 1.5
4-7.
HOW TO INSTALL THE STOCKER ASSY
1 Fit three shafts of the stocker assy in respective slits
of the cams (stocker U/D).
Note: For the location of slits of the cams (stocker U/D),
see 4-6. HOW TO INSTALL CAM (STOCKER U/D).
cam (stocker U/D)
cam (stocker U/D)
shaft
stocker assy
shaft
cam (stocker U/D)
cam (stocker U/D)
cam (stocker U/D)
shaft
stocker assy
pulley (stocker)
pulley (stocker)
A
2 Making sure that three shafts of the stocker assy fit in
respective slits of the cams (stocker U/D), rotate the
pulley (stocker) in the direction of arrow A by hand to
store the stocker assy.
22
HCD-C770/C990
Ver 1.5
4-8.
PHASE ADJUSTMENT BETWEEN PINIONS (SLIDER) AND SLIDER-1 TO 5 (L/R)
1 As shown in the following figure, adjust the portion A of each slider to the boss with the
slider-1 to 5 (L) and the slider-1 to 5 (R) pushed in the arrow directions respectively (see Fig. 1).
2 Paying attention to the up/down direction of the pinion (slider) (see Fig. 2), install each pinion (slider)
so that the portion B of each pinion (slider) meshes with the portion A of each slider (see Fig. 3).
Note: Push in the pinion (slider) until the claw of the boss comes out above the pinion (slider) to lock.
A
boss
pinion (slider)
A
A
boss
pinion (slider)
A
slider-5 (R)
A
slider-5 (L)
boss
A
pinion (slider)
slider-4 (L)
slider-4 (R)
slider-3 (L)
slider-3 (R)
slider-2 (L)
slider-2 (R)
slider-1 (L)
A
slider-1 (R)
boss
(Fig. 1)
pinion (slider)
A
boss
claw
A
pinion (slider)
boss
pinion (slider)
A
(Fig. 2)
boss
pinion (slider) portion B
pinion (slider) portion B
slider portion A
slider portion A
claw
(Fig. 3)
23
HCD-C770/C990
SECTION 5
TEST MODE
Ver 1.4
[GENERAL DESCRIPTION]
The Test Mode allows you to make diagnosis and adjustment easily
using the remote commander and monitor TV. The instructions,
diagnostic results, etc. are given on the on-screen display (OSD).
[TEST DISC LIST]
Use the following test disc on test mode.
TDV-520CSO (DVD-SL): PART No. J-2501-236-A
LIV-P01 (CD):
PART No. 4-999-032-01
TDV-540C (DVD-DL):
PART No. J-2501-235-A
0-1. All (All items continuous check)
This menu checks all diagnostic items continuously. Normally, all
items are checked successively one after another automatically
unless an error is found, but at a certain item that requires judgment
through a visual check to the result, the following screen is displayed
for the key entry.
• Example display
### Syscon Diagnosis ###
Note: Do not use exiting test disc for DVD.
[STARTING TEST MODE]
1. Press the [POWER] button to turn the power on, and set the
2.
3.
function to DVD.
While pressing the x and [DISPLAY] button, turn the
[VOLUME] knob clockwise to enter the test mode.
It displays “TEST MODE” on the fluorescent indicator tube,
and displays the Test Mode Menu on the monitor screen as
follows. (At the bottom of the menu screen, the model name
and revision number are displayed)
Diag All Check
No.2 Version
2-3. ROM Check Sum
Check Sum = 2320
Press NEXT Key to Continue
Press PREV Key to Repeat
Test Mode Menu
0.
1.
2.
3.
4.
5.
6.
Syscon Diagnosis
Drive Auto Adjustment
Drive Manual Operation
Mecha Aging
Emergency History
Version Information
Video Level Adjustment
For the ROM Check, the check sum calculated by the Syscon is
output, and therefore you must compare it with the specified value
for confirmation.
Following the message, press the [NEXT > ] button to go to the
next item, or press the [. PREV] button to repeat the same
operation again.
To quit the diagnosis and return to Check Menu screen, press the
[RETURN] key on the remote commander to display Check Menu.
Exit: POWER Key
Model
:DAV-Cxxx
Revision :x.xx
4.
5.
To execute each function, select the desired menu and press its
number on the remote commander (RM-SS880J).
To release from test mode, press the [POWER] button and turn
the power off.
[OPERATING TEST MODE]
0.
SYSCON DIAGNOSIS
The same contents as board detail check by serial interface can be
checked from the remote commander operation.
On the Test Mode Menu screen, press [10/0] key on the remote
commander, and the following Check Menu will be displayed.
### Syscon Diagnosis ###
Check Menu
0.
1.
2.
3.
4.
5.
6.
7.
Quit
All
Version
EEPROM
SPIO
SD Bus
Video
Audio
0-0. Quit
Quit the Syscon Diagnosis and return to the Test Mode Menu.
24
• Error occurred
If an error occurred, the diagnosis is suspended and error is displayed.
Press the [RETURN] key on the remote commander to quit the
diagnosis, or press the [. PREV] button to repeat the same check
where an error occurred, or press the [NEXT>] button to continue
the check from the item next to faulty item.
General Description of Checking Method
Selecting 2 and subsequent items calls the submenu screen of each
item. And selecting 2 and subsequent items executes respective
menus and outputs the results.
For the contents of each submenu, see “Check Items List” as below.
Check Items List:
0-2. Version
0-2-1. All
0-2-2. Revision
0-2-3. ROM Check Sum
0-2-4. Model Type
0-2-5. Region
0-3. EEPROM Check
0-3-1. Sampling Check
0-3-2. Detail Check
0-4. GP I/O Check
0-5. SD Bus Check
0-6. Video Check
0-7. Audio Check
0-2. Version
0-2-2. Revision
The revision number of ROM (IC204) that the program for
the DVD system processor (IC206) is stored.
(4 digits hexadecimal number)
HCD-C770/C990
0-2-3. ROM Check Sum
The revision number of ROM (IC204) that the program for
the DVD system processor (IC206) is stored.
0-2-4. Model Type
Model name is displayed. (DAV-C770 or DAV-C990)
0-2-5. Region
Model destination code is displayed. (2 digits number)
0-3. EEPROM Check
0-3-1. Sampling Check
EEPROM check at every 64 words.
It compares read data with write data of each address. When
there are discrepancies between two data, it displays error.
0-3-2. Detail Check
EEPROM check at every 1 word.
It compares read data with write data of each address. When
there are discrepancies between two data, it displays error.
0-4. GP I/O Check
Pull up/down setting check of the DVD system processor (IC206)
pin 150, 151 and 154 (for clock setting port).
0-5. SD Bus Check
SD bus data check between DVD decoder (IC701) and D-RAM
(IC706).
0-6. Video Check
Output the color bars for video level adjustment.
0-7. Audio Check
Output the test signal (1kHz sine wave) for 5.1 CH test.
1.
DRIVE AUTO ADJUSTMENT
On the Test Mode Menu screen, press the [1] key on the remote
commander, and the Adjustment Menu will be displayed.
## Drive Auto Adjustment ##
Adjustment Menu
0.
1.
2.
3.
ALL
DVD-SL
CD
DVD-DL
specified disc following the message. You can finish the adjustment
by pressing the [RETURN] button on the remote commander.
Note: During adjustment of each disc, the measurement for disc type judgment is made. As automatic adjustment does not judge the disc
type unlike conventional models, take care not to insert wrong type
discs. Also, do not give a shock during adjustment.
1-1. DVD-SL (single layer)
Press the [1] key on the remote commander and insert a DVD single
layer disc following the message. Then the adjustment will be made
through the steps below, then adjusted values will be written to the
EEPROM.
DVD Single Layer Disc Adjustment Steps:
1. Sled tilt reset
2. Disc check memory SL
3. Wait 300 msec
4. Set disc type SL
5. LD on
6. Spindle start
7. Wait 1 sec
8. Focus servo on 0
9. Auto track offset adjust
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. Wait 1 sec
14. Sled on
15. Check CLV on
16. Auto LFO adjust
17. Auto focus offset adjust
18. Auto tilt position adjust
19. Auto focus gain adjust
21. EQ boost adjust
22. Auto loop filter offset adjust
23. Auto track gain adjust
Search Check
24. 32 track jump forward
25. 32 track jump reverse
28. All servo stop
29. EEP copy loop filter offset
1-2. CD
Press the [2] key on the remote commander and insert a CD disc
following the message. Then the adjustment will be made through
the steps below, then adjusted values will be written to the EEPROM.
Exit: RETURN
Normally, [10/0] is selected to adjust DVD (single layer), CD and
DVD (dual layer) in this order. But, individual items can be adjusted
for the case where adjustment is suspended due to an error. In this
mode, the adjustment can be made easily through the operation
following the message displayed on the screen.
The disc used for adjustment must be the one specified for
adjustment.
1-0. ALL
Press the [10/0] key on the remote commander, and the servo set
data in EEPROM will be initialized. Then, 1. DVD-SL disc, 2. CD
disc and 3. DVD-DL disc are adjusted in this order.
Each time one disc was adjusted, it is ejected. Replace it with the
CD Adjustment Steps
1. Sled tilt rest
2. Disc check memory CD
3. Wait 500 msec
4. Set disc type CD
5. LD on
6. Spindle start
7. Wait 500 msec
8. Focus servo on 0
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. (TC display start)
14. Wait 1 sec
15. Jitter display start
16. Sled ON
25
HCD-C770/C990
17. Check CLV on
22. EQ boost adjust
23. Auto LFO Adjust
Search Check
25. 32Tj forward
26. 32Tj reverse
27. 500Tj forward
28. 500Tj reverse
29. All servo stop
1-3. DVD-DL (dual layer)
Press the [3] key on the remote commander and insert a DVD dual
layer disc following the message. Then the adjustment will be made
through the steps below, then adjusted values will be written to the
EEPROM.
DVD Dual Layer Disc Adjustment Steps:
1. Sled tilt reset
2. Disc check memory DL
3. Wait 500 msec
4. Set disc type DL
5. LD on
6. Spindle start
7. Wait 1 sec
Layer 1 Adjust
8. Focus servo on 0
10. CLVA on
11. Wait 500 msec
12. Tracking on
13. Wait 500 msec
14. Sled on
15. Check CLV lock
16. Auto loop filter offset adjust, Auto focus adjust
19. EQ boost adjust
21. Auto Track Gain Adjust
Search Check
Layer 0 Adjust
26. Focus jump (L1 t L0)
27. Auto track offset adjust L0
28. CLVA on
29. Wait 500 msec
30. Tracking on
31. Wait 500 msec
32. Sled on
33. Check CLV lock
34. Auto focus filter offset adjust
35. Auto Focus Adjust
38. EQ boost adjust
39. Auto Loop Filter Offset
Search Check
26
Layer Jump Check
45. Layer jump (L0 ? L1)
46. Layer jump (L1 ? L0)
47. All servo stop
2.
DRIVE MANUAL OPERATION
Note: This mode is used for design, and not used in service fundamentally.
On the Test Mode Menu screen, press the [2] key on the remote
commander, and the Operation Menu will be displayed. For the
manual operation, each servo on/off control and adjustment can be
executed manually.
## Drive Manual Operation ##
Operation Menu
1. Disc Type
2. Servo Control
3. Track/Layer Jump
4. Non EEPROM Write Adjust
5. EEPROM Write Adjust
6. Memory Check
7. Disc Check Memory
8. Error Rate Display
9. SACD Water Mark
Exit: RETURN
In using the manual operation menu, take care of the following
points. These commands do not provide protection, thus requiring
correct operation. The sector address or time code field is displayed
when a disc is loaded.
Note:
1. Set correctly the disc type to be used on the Disc Type screen.
2. In case of an alarm, immediately press the x button to stop the
servo operation, and press the [POWER] button to turn the power
off.
Basic operation:
(controllable from front panel or remote commander)
[POWER]
: Power OFF (release the Test Mode)
x
: Servo stop
Z (DISC1 to 4)
: Stop and eject/Loading
[RETURN]
: Return to Operation Menu or Test
Mode Menu
[. PREV], [NEXT>] : Transition between sub modes of menu
[1] to [9], [10/0]
: Selection of menu items
Cursor o / O
: Increase/Decrease in manually
adjusted value
HCD-C770/C990
2-1. Disc Type
Disc Type
Disc Type Select
1.
2.
3.
4.
Disc Type Auto Check
Set Disc Type DVD
Set Disc Type CD
Set Disc Type Hybrid
Exit: RETURN
2-1-1.
1) Press the [1] key on the remote commander to display the Disc
Type Auto Check screen.
2) Insert a disc and press the [ENTER] key on the remote
commander.
3) It judges the type of inserted disc automatically and displays
the disc type and so on as below.
Disc Type
Layer
xx
Mirr Time
Mirr Count
FZC Count
PI Reference
PI Peak xx
xx
xx
xx
xx
xx
2-1-3. Disc Type CD
It sets up so that it may judge as a disc type of specification of the
disc with which the set was inserted.
[1]: CD disc (normal speed, 12 cm)
[2]: CD disc (double speed, 12 cm)
[3]: CD disc (normal speed, 8 cm)
[4]: CD disc (double speed, 8 cm)
[5]: CD-RW disc (normal speed, 12 cm)
[6]: CD-RW disc (double speed, 12 cm)
[7]: CD-RW disc (normal speed, 8 cm)
[8]: CD-RW disc (double speed, 8 cm)
2-1-4. Disc Type Hybrid
[1]: SACD Hybrid disc (SACD layer, 12 cm)
[2]: SACD Hybrid disc (CD layer, normal speed, 12 cm)
[3]: SACD Hybrid disc (CD layer, double speed, 12 cm)
[4]: SACD Hybrid disc (SACD layer, 8 cm)
[5]: SACD Hybrid disc (CD layer, normal speed, 8 cm)
[6]: SACD Hybrid disc (CD layer, double speed, 8 cm)
2-2. Servo Control
Note: Be sure to perform the disc type setup before performing this item.
Servo Control
1.LD
off R.Sled
2.Focus
off L.Sled
3.SPDL
off U.Sled
4.CLVA
off D.Sled
5.Trk.
off
6.Sled
off
7.Fcs.Srch
off
8.Fcs.OppL
off
FWD
REV
Reset
Limit
0.All Servo Off
ENTER.Execute
Exit: RETURN
Exit: RETURN
Disc Type
Layer
Mirr Time
: CD, DVD or Hybrid (SACD)
: SINGLE, DUAL or HYBRID
: Mirror time of between disc surface and record
surface when disc type judgment. (hexadecimal
number)
Mirr Count : The number of times which mirror counts between
disc surface and record surface when disc type
judging. (hexadecimal number)
FZC Count : The number of times which focus zero cross points
of each layer when lens down. (hexadecimal number)
PI Reference : The average of PI reference voltage. (hexadecimal
number)
PI Peak
: PI peak level voltage. It performs only when disc
type judgment is successful. (hexadecimal number)
2-1-2.
Disc Type DVD
[1]: DVD single layer disc (12 cm)
[2]: DVD dual layer disc (0 layer, 12 cm)
[4]: DVD-RW disc (12 cm)
[5]: DVD single layer disc (8 cm)
On this screen, the servo on/off control necessary for replay is
executed. Normally, turn on each servo from 1 sequentially and
when CLVA is turned on, the usual trace mode becomes active. In
the trace mode, DVD sector address or CD time code is displayed.
This is not displayed where the spindle is not locked.
The spindle could run overriding the control if the spindle system is
faulty or RF is not present. In such a case, do not operate CLVA.
[1] LD
[2] Focus
[3] SPDL
[4] CLVA
[5] Trk.
[6] Sled
[7] FCS. Srch
[8] FCS. OppL
: Turn on/off the laser.
: Search the focus and turn on the focus.
: Turn on/off the spindle.
: Turn on/off normal servo of spindle servo.
: Turn on/off the tracking servo.
: Turn on/off the sled servo.
: Turn on/off the focus search.
: Turn on/off the focus search to another layer
of designated layer in Disc Type setting. (dual
layer disc only)
[10/0]
: All servo off.
[R] Sled FWD (right cursor) : Move the sled forward.
[L] Sled REV (left cursor) : Move the sled reverse.
[U] Sled FWD (up cursor) : Reset the sled.
[D] Sled REV (down cursor) : Limit in the sled.
27
HCD-C770/C990
2-5. EEPROM Write Adjust
2-3. Track/Layer Jump
1. 1Tj
2. 1Tj
3.500Tj
4.500Tj
5.10kTj
6.10kTj
7.20kTj
8.20kTj
Track/Layer Jump
FWD R.Lj L0>L1
REV L.Lj L1>L0
Fine
FWD U.Fj L0>L1
Fine
REV D.Fj L1>L0
Dirc
FWD
Dirc
REV
Dirc
FWD
Dirc
REV
EEPROM Write Adjust
1.
2.
3.
4.
5.
6.
Focus
Focus
Trk.
——————
Trk.
EQ
Offset
Gain
Offset Coarse
Gain
Boost
0.All Servo Off
0. All Servo Off
Exit: RETURN
On this screen, track jump, etc. can be performed. Only for the DVD
dual layer disc, the focus jump and layer jump are displayed in the
right field
[1] 1Tj FWD : 1 track jump forward.
[2] 1Tj REV : 1 track jump reverse.
[3] 500Tj FWD: 500 track jump (fine search)forward.
[4] 500Tj REV : 500 track jump (fine search) reverse.
[5] 10kTj FWD: 10k track jump (direct search) forward.
[6] 10kTj REV : 10k track jump (direct search) reverse.
[7] 20kTj FWD: 20k track jump (direct search) forward.
[8] 20kTj REV : 20k track jump (direct search) reverse.
[10/0]
: All servo off.
2-4. Non EEPROM Write Adjust
Non EEPROM Write Adjust
1.
2.
3.
4.
5.
6.
Focus
Focus
Trk.
Trk.
Trk.
EQ
Offset
Gain
Offset Coarse
Offset Fine
Gain
Boost
0.All Servo Off
Exit: RETURN
On this screen, each item can be adjusted manually. Select the desired
number [1] to [10/0] from the remote commander, and current
setting for the selected item will be displayed, then increase or
decrease numeric value with the O key or o key. This value is
stored in the EEPROM. If CLV has been applied, the jitter is
displayed for reference for the adjustment.
Exit: RETURN
On this screen, each item can be adjusted automatically. Select the
desired number [1] to [10/0] from the remote commander, and
selected item is adjusted automatically.
[1] Focus Offset : Adjusts focus offset.
[2] Focus Gain : Adjusts focus gain.
[3] TRK. Offset : Adjusts tracking offset of the RF amp
(IC001) side.
[5] TRK. Gain : Adjusts track gain.
[6] EQ Boost : Adjusts amount of boost of equalizer.
[10/0]
: All servo off.
2-6. Memory Check
Display images are shown as follows, and all two screens are able
to switch by the O key (UP) or o key (DW).
EEPROM Data 1/2
CD
Focus Gain
xx
Trk.
Gain
xx
Focus Offset
xx
Trk.
Offset
xx
EQ.
Boost
xx
PI
Level
xx
Fcs. Balance
-Jitter xx
xx
Mirror Time
xx
FE Level
-Traverse Lv1.
-Next:DW Default:CLR
EEPROM
Focus
Trk.
Focus
Trk.
EQ.
Data 2/2
Gain
Gain
Offset
Offset
Boost
SL L0 L1
xx xx xx
xx xx xx
xx xx xx
xx xx xx
xx xx xx
xx -- -xx -- -xx xx
xx xx -xx -- -xx -- -Exit:RET
CDRW DVDRW
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
[1] Focus Offset : Adjusts focus offset.
[2] Focus Gain : Adjusts focus gain.
[3] TRK. Offset : Adjusts tracking offset of the RF amp
(IC001) side.
[4] TRK. Offset : Adjusts tracking offset of the DSP (IC401)
side.
[5] TRK. Gain : Adjusts track gain.
[6] EQ Boost : Adjusts amount of boost of equalizer.
[10/0]
: All servo off.
28
Next:UP Default:CLR
Exit:RET
On this screen, current servo adjusted data stored in the EEPROM
are displayed. The adjusted data are initialized by pressing the
[CLEAR] key, but be careful that they are not recoverable after
initialization.
Before clearing the adjusted data, make a note of the set data. This
screen will also appear if [0]-All is selected in the Drive Auto
Adjustment. In this case, default setting cannot be made.
HCD-C770/C990
2-7. Disc Check Memory
3.
Disc Check Memory
MECHA AGING
On the Test Mode Menu screen, selecting [3] executes the aging of
the mechanism deck.
1. SL Disc check
2. SL Disc check
3. SL Disc check
### Aging Test MENU ###
Operation Menu
1. Open/Close Test
Exit: RETURN
On this screen, measure the mirror time of chucked disc, and write
to the EEPROM.
2-8. Error Rate Display
Exit: RETURN
1)
Error Rate Display
UC
CR ADD
PI1 Err Now xx xxxx xxxxxxxx
Max xx xxxx xxxxxxxx
Avg xx xxxx xxxxxxxx
PI2 Err Now xx xxxx xxxxxxxx
PO Err Now xx xxxx xxxxxxxx
Exit: RETURN
2)
3)
On the Aging Test MENU screen, press the [1] key on the
remote commander to display the Open/Close Test screen.
Insert discs and press the [ENTER] key on the remote
commander.
Is starts the aging.
During aging, the disc number, operating status and repeat cycle
are displayed. Aging can be aborted at any time by pressing
the x key. After the operation is stopped, press the x key or
[RETURN] key aging to return to the Aging Test MENU.
4. EMERGENCY HISTORY
On the Test Mode Menu screen, selecting [4] displays the
information such as servo emergency history.
The history information from last 1 up to 10 can be scrolled with
the O key or o key. Also, specific information can be displayed
by directly entering that number with ten keys.
On this screen, measure and display the error rate.
UC : Incorrect value
CR : Correct value
Add : Address
### EMG. History ###
Laser Hours
CD
xxxxhxxm
DVD xxxxhxxm
2-9. SACD Water Mark Check
a.
bb xx xx xx
xx xx xx xx
xx xx xx xx
xx xx xx xx
a.
bb xx xx xx
xx xx xx xx
xx xx xx xx
xx xx xx xx
SACD Water Mark Check
PSP AMP
PSN
Start: ENTER
Select:1-9
(1.Latest EMG.)
Exit: RETURN
On this screen, measure the PSP AMP value and PSN value of SACD
water mark.
Scroll:UP/DOWN
Exit: RETURN
xxxxhxxm : The laser on total hours. Data below minutes are
omitted.
a.
: Error number.
bb
: Error code.
xx
: Not used.
• Clearing History Information
Clearing laser hours:
Press the [DVD DISPLAY] and [CLEAR] keys in this order.
Then both CD and DVD data are cleared.
Clearing emergency history:
Press the [DVD TOP MENU] and [CLEAR] keys in this order.
Initializing set up data:
Press [DVD MENU] and [CLEAR] keys in this order.
The data have been initialized when “Set Up Initialized”
message is displayed. The EMG. History screen will be restored
soon.
29
HCD-C770/C990
• Code list of Emergency History
10: Communication to RF AMP (IC001) failed.
11: Each servo for focus, tracking, and spindle is unlocked.
12: Check sum error of EEPROM (IC203).
14: Communication to servo DSP (IC401) failed, or servo DSP
decoder (IC801) is faulty.
15: Communication to DVD decoder (IC701) failed, or DVD
16: Communication to DSD decoder (IC801) failed, or DSD
20: Initialization of sled servo failed. It is not placed in the initial position.
23: Sled servo operation error.
24: Made a request to move the sled servo to wrong position.
30: Tracking balance adjustment error.
31: Tracking gain adjustment error.
33: Focus bias adjustment error.
34: Focus gain adjustment error.
35: Equalizer adjustment error.
40: Focus servo does not operate.
41: With a DVD dual layer disc, focus jump failed.
50: CLV (spindle) servo does not operate.
51: Spindle does not stop.
60: Made a request to seek nonexistent address.
61: Seek error of retry more than regulated times.
70: Control data could not be read.
80: Disc reading failed.
5. MECHA ERROR HISTORY
On the Test Mode Menu screen, selecting [5] displays the information
of mechanism deck error history.
The history information from last 1 up to 8 can be scrolled with the
O key or o key. Also, specific information can be displayed by
directly entering that number with ten keys.
### Mecha Error History ###
1.
2.
3.
4.
5.
6.
7.
8.
aa
aa
aa
aa
aa
aa
aa
aa
bb
bb
bb
bb
bb
bb
bb
bb
cc
cc
cc
cc
cc
cc
cc
cc
dd
dd
dd
dd
dd
dd
dd
dd
(1.Latest Err.)
aa :
bb :
cc :
dd :
xx :
30
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
xx
Scroll:UP/DOWN
Exit: RETURN
The error in the midst of initializing the mechanism deck.
The error in the midst of loading operation.
The error in the midst of up/down the stocker.
The error in the midst of switching the mechanism deck mode.
Not used.
• Error code (aa)
FF : Complete the initializing. (normal operation)
11 : Stocker movement (to chucking position) failing in the midst
of initializing the mechanism deck.
12 : Stocker movement (to chucking position) failing in the midst
of initializing the mechanism deck.
1x : Initializing the mechanism deck.
41 : Disc eject failing in the midst of initializing the mechanism
deck.
50 : Disc eject failing in the midst of initializing the mechanism
deck.
A2 : Disc eject failing in the midst of initializing the mechanism
deck.
Ax : Initializing the mechanism deck.
D3 : Disc eject failing in the midst of initializing the mechanism
deck.
Dx : Initializing the mechanism deck.
Ex : Initializing the mechanism deck.
• Error code (bb)
00 : Initializing the mechanism deck.
10 : Retry over of eject and loading.
30 : Open operation in no disc status.
60 : Retry over of eject and loading.
70 : Disc is chucking position.
81 : Retry failed of disc movement from chucking position to
stocker.
83 : Retry preparation failed of disc movement from chucking
position to stocker.
90 : Disc is stored in the stocker.
A1 : Retry failed of disc movement from stocker to chucking
position.
A3 : Retry preparation failed of disc movement from stocker to
chucking position.
B0 : Just before the release operation.
B1 : Retry failed of the release operation.
• Error code (cc)
10 : Under a stop.
22 : Retry preparation failed.
23 : Retry failed.
• Error code (dd)
10 : Under a stop.
22 : Retry preparation failed.
23 : Retry failed.
HCD-C770/C990
SECTION 6
ELECTRICAL ADJUSTMENT
6.
VERSION INFORMATION
AUTO SERVO ADJUSTMENT
On the Test Mode Menu screen, selecting [6] displays the ROM
version and region code.
The parenthesized hexadecimal number in version field is
checksum value of ROM.
After parts related to the servo circuit (RF amplifier (IC001), DSP
(IC401), motor driver (IC501), EEPROM (IC302) so on) are replaced, re-adjusting the servo circuit is necessary. Select “ALL” at
“1. DRIVE AUTO ADJUSTMENT” (Refer to page 25 in TEST
MODE) and adjust DVD-SL (single layer), CD and DVD-DL (dual
layer).
## Version Information ##
IF con.
Ver.x. xx
SYScon.
Ver.x. xx (xxxx)
Model
DAV-Cxxx
Region
0x
Front End Ver.x.xx
Exit: RETURN
IF con. : The version of system controller (IC901).
SYScon. : The version of DVD system processor (IC206).
Front End : The version of mechanism controller (IC301).
7. VIDEO LEVEL ADJUSTMENT
On the Test Mode Menu screen, selecting [7] displays color bars
for video level adjustment. During display of color bars, OSD disappears but the menu screen will be restored if pressing the [RETURN] key.
31
31
Ver 1.4
HCD-C770/C990
SECTION 7
DIAGRAMS
7-1.
BLOCK DIAGRAM – RF SERVO Section –
• SIGNAL PATH
WARFI
: AUDIO
: CD PLAY
CDDOUT
: DVD PLAY
: VIDEO
: SACD PLAY
HDB0 – HDB7
DOUT 64
RF
1 DVDRFP
ATOP 62
59 AIP
FNP 53
54 DIP
63 RFSIN
ATON 61
60 AIN
FNN 52
55 DIN
RFAC 57
50 RFAC
PCMD 66
160 MDAT
44, 41, 39, 35,
32, 30, 27, 24
117 RFIN
A
(Page 33)
B
(Page 33)
SD0 – SD7
(for AUDIO SYSTEM)
C
AV DATA BUS
D
XTAI 71
TRK+
TRK–
BUFFER
40
36
37
FOCUS COIL
DRIVE
48
1
34
35
TRACKING COIL
DRIVE
FE
PI
AVC
(1.65V)
42
3
4
M
32
31
30
29
SLED MOTOR
DRIVE
7
SLED MOTOR
DRIVE
TE
SE
FE
LOCK 24
GFS 13
MUTE 3
75 LOCK CD
71 GFS CD
59 MUTE CD
RFDC
38 VC
42 CE
FF
FR
FF
FR
TF
TR
FF
FR
M2
(SLED)
41
40
39
43
76 28
31
SLED 61
(Page 33)
WE
OE
RAS
UCAS
LCAS
H
(Page 33)
I
(Page 35)
J
(Page 33)
K
(Page 33)
L
(Page 35)
M
(Page 33)
I/O0 – I/O15
17
33
18
34
35
MDB0 – MDB9,
MDBA – MDBF
76
94
78
95
107 GFS
164 XRST
109 92
53
768FS
XRST_DSD
COUT 19
SCLK 8
FOK 22
MIRR 20
30
72
74
29
COUT CD
SCLK CD
FOK CD
MIRR
JIT OFFSET 45
XSRQ
JIT 64
SACD/DVD
SELECT
IC814
COMPARATOR
IC703 (1/2)
XSRQ-ZIVA
SACD/DVD 77
SPINDLE MOTOR
DRIVE
13
47
46
BUFFER
45
SDATA RF
SDCLK RF
SDEN
83 82 2
27
28
6
EEP SI 5
EEP CLK 100
EEP CS 99
65 67 66
PI
63 SP ON
73 TSD
EEP RDY
TE
FE
PI
60 MUTE 2D
TE
FE
19
20
21
22
DATA_RF
CLK_RF
SDEN
MIRR
M
WE
XMOE
XRAS
XCAS
27M
29 SFDR
30 SRDR
G
16Mbit
D-RAM
IC706
31 TFDR
32 TRDR
AMP
IC402 (1/2)
(Page 35)
10
MUTE12
MUTE34
MUTE5
TSD-M
M1
(SPINDLE)
XRD
XWR
XCS
XINT0
XINT1
XRST DVD 25
7 FCS JMP 1
8 FCS JMP 2
44 SLED B
43 SLED A
17
18
19
20
21
GFS DVD 58
33 FFDR
34 FRDR
TF
TR
85
84
12
22
23
XRD
XWR
XCS DVD
INT0 DVD
INT1 DVD
A0 – A9
FOCUS/TRACKING COIL DRIVER,
SPINDLE, SLED MOTOR DRIVER
IC501
INLIM
FCS+
FCS–
TE
LDSEL
LD ON
2AXIS
DEVICE
FOCUS/
TRACKING
COIL
LASER DIODE
SELECT
Q301
DATA CD
CLOK CD
LAT CD
SENS CD
SQSO
SQCK
2-5, 7-10,
41-44, 46-49
49
50
27
9
52
54
XSRQ
26 SCOR
DATA 4
CLOK 6
XLAT 5
SENS 7
SQSO 76
SQCK 77
AEP0
SCOR 15
26 SSTP
INLIM
SW
3 DOCTR/
ISBTEST
MNT1
MD2 63
36 V125
WCK
F
2
21 DVDLD
LDON 26
(Page 33)
137 MDIN2
135 SPO
98
MIRR
MIRR 27
E
XDCK, XSAC,, SDEFF
(for VIDEO SYSTEM)
21-24,
27-32
XRST
XDCK
XSAC
SDEF
XSHD
66-69, 71, 73-75, 96, 97,
99, 101, 102, 104-106
TE
FE
PI
TE 39
FE 40
MNTR 42
48
46
26
49
MNT2 93
D0 – D7
22 CDLD
BUFFER
IC703 (2/2)
MDP 25
XDCK
XSAK
HDB8
XSHD
167 XTA1
169 XTA2
170 XTAL
172-176, 1, 2, 4
SDATA 47
SCLK 46
SDEN 48
XDCK, XSAC, SDEF, XSHD
(for AUDIO SYSTEM)
79, 80, 82-87,
89, 91
DATA_RF
CLK_RF
SDEN
WFCK
SBIN
EXCK
SCOR
(Page 35)
DVD DECODER
IC701
10 3 13 9
24 CDPD
23 DVDPD
AUTOMATIC POWER
CONTROL (FOR DVD)
Q001
CLOCK
GENERATOR
IC303
8
151
148
147
150
A0 – A7
LASER
DVD LD
DIODE
(FOR DVD)
7
BCK
LRCK
C2PO
GSCOR
5, 7, 9-14
PD
CD A
CD B
CD C
CD D
CD/DVD/SACD RF AMP,
FOCUS/TRACKING ERROR AMP
IC001
X302
27MHz
D0 – D7
14-21
AUTOMATIC POWER
CONTROL (FOR CD)
Q002
16
15
14
13
DIGITAL SIGNAL PROCESSOR,
DIGITAL SERVO PROCESSOR
IC401
WFCK
SBSO
EXCK
SCOR
158
163
155
146
A0 – A7
89-96
CD LD
B
A
D
C
A
B
C
D
WFCK
SBSO
EXCK
SCOR
XDRST
OPTICAL PICK-UP
BLOCK
(TDP022W)
12
11
10
9
BCLK
LRCK
C2PO
GSCOR
BCLK
LRCK
C2PO
GSCOR
MA0 – MA9
17 CD F
B
A
D
C
LASER
DIODE
(FOR CD)
WFCK 10
SBSO 79
EXCK 80
18 CD E
E
67
65
14
17
SO2
XTI
MO1
SO3
XTO
SO1
F
BCLK
LRCK
C2PO
WDCK
A2
B2
C2
D2
27M
768FS
3
4
5
6
D
C
B
A
DETECTOR
A
B
C
D
(Page 33)
SD0 – SD7
(for VIDEO SYSTEM)
MECHANISM
CONTROLLER
IC301 (1/2)
62 FG
32
32
SDIN DSD
SDOUT DSD
SCK DSD
XMSLAT
READY DSD
MUTE DSD
47
46
24
51
48
53
5 SDA
6 SCL
7 WP
EEPROM
IC302
MSDATO
MSDATI
MSCK
XMSLAT
SHRRDY
SHRMUT
MSDATO, MSDATI, MSCK,
XMSLAT, SHRRDY, SHRMUT
HCD-C770/C990
7-2.
BLOCK DIAGRAM – AUDIO (DSP) Section –
D5V
REFERENCE VOLTAGE
GENERATOR
IC402 (2/2)
MSDATO
MSDATI
MSCK
XMSLAT
SHRRDY
SHRMUT
6
4
3
2
7
10
XRST_DSD
TDOSA
TDISA
TCK
TMS
TRST
29
27
26
30
31
CKOUT 49
F2BCK 43
F2LRCK 44
22 KFSIO
17 BCKI1
15 LRCKI1
SCKOUT
BCKO
LRCKO
GP10
EXID1
MSDATO
MSDATI
MSCK
XMSLAT
MSREADY
SMUTE
TDO
TDI
TCK
TMS
TRST
XWE
XRAS
XCAS
DCKE
DCLK
(Page 35)
O
15
17
16
34
35
WE
RAS
CAS
CKE
CLK
OPTICAL RECEIVER
IC204
X600
12.288MHz
J205 (1/4)
L
R-CH
R
: AUX IN
: OPTICAL
DIGITAL IN
: TUNER
57 EXID2
BCK2
LRCK2
29 BCK2
28 LRCK2
79 INIT
78 SYNC
77 SELEXT
CKOUT
BCK
LRCK
DIGITAL AUDIO
INTERFACE
IC606
DI
DO
22 XIN
CL
CE
XSTATE
21 XOUT
XMODE
20 XMCK
ERROR
AUDIO
: SACD PLAY
59 EXIMCK
55 EXIBCK
56 EXILRCK
EXID2
9 MCLK1
X601
13.5MHz
S-RAM
IC604
CS0 44
WE0 45
41 OE
17 WE
EXID1
DATA 16
5 DIN2
4 DIN1
3 DIN0
SPDIF
VIDEO 1
AUDIO IN
: CD PLAY
58 EXID1
EXIMCK
EXIBCK
EXILRCK
16Mbit
SD-RAM
IC808
143
145
144
142
141
CDDOUT
OPTICAL
DIGITAL IN
VIDEO 2
DIGDI
DIGCLK
EXIMCK
EXIBCK
EXILRCK
13
14
15
33 HDIN
34 HCLK
35 HDOUT
32 HACN
68 GP9
PLOCK
DIGDI
DO
DIGCLK
CSDIR
XST
RSTDIR
36
35
38
37
17
48
34
24
PM
HCS
BST
RSTDSP
PM 113
HCS 36
BST 56
XRST 2
59 69
DIGDI, DIGCLK
ENABLE
SWITCH
Q908 – 910
DET AMP
Q201
FM-DET
(AEP)
(Page 35)
(Page 34)
P
S
AV0 – AV2
RSTAD
Q206
16 6
X1
RDATA 2
RCLK 16
X0
13
14
4 MUX
X201
4.332MHz
33 AD-RST
TUDI
TUDO
TUCLK
TCE
TUN
RDSD
RDSC
RDS DECODER
IC201
RDSD
RDSC
(AEP)
AV0
AV1
AV2
52
54
55
53
51
PM
HCS
BST
RSTDSP
65 98
97
7 25 8 20 24
22 18
6 15 17
19
23
28
13 14 16 12
DSP-PM
DSP-CS
DSP-BST
DSP-RST
Q205
DAMP-MUTEN
TUDI
TUDO
TUCLK
TCE
TUN
AV0
DI
DO
CK
CE
TUNED
AV2
GND
D903
DIR-AD
AM ANT
AM
BCK2
LRCK2
RSTDIR
BCK 14
LRCK 13
DIR-ERR
R-CH
5 RIN
DSP-DO
DSP-HACN
DSP-GP9
R-CH
R-CH
DIGDI
DO
DIGCLK
CSDIR
L-CH
DOUT 15
NSMUTE
DIR-XST
DIR-ZERO
GND
1 LIN
EXID2
Q903
LEVEL SHIFT
IC900
DIG-DI
DI
DIG-CLK
DIR-CE
DIR-XMODE
FM ANT
AMP
Q221
LOW-PASS
FILTER
IC603
TUN-DI
TUN-DO
TUN-CLK
TUN-CE
TUNED
88 RDS-DATA
94 RDS-CLK
SYSTEM CONTROLLER
IC901 (1/3)
95 AV-SEL0
96 AV-SEL1
48 AV-SEL2
33
33
R
(Page 34)
POWER ON
MUTING
Q490, 492
DF-SW
COAXIAL
FM
75Ω
A/D CONVERTER
IC602
SYSCLK
RSTB
2 Y2
1 Y0
Y 3
5 Y1
A B
10 9
FM/AM TUNER PACK
XST
PLOCK
AUDIO INPUT
SELECTOR
IC202
R-CH
(Page 34)
12V
DFIL RST2
DF-SYNC
L
R
T
D490
J206 (1/3)
VIDEO 2
AUDIO IN
: AUDIO
EXLOCK
GP8
B
SCK
BCKO
LRCKO
14
20
19
67
DIGITAL AUDIO
SIGNAL PROCESSOR
IC607
12 MCLK2
(Page 32)
• R-ch is omitted due
to same as L-ch.
• SIGNAL PATH
D3
: DVD PLAY
164 XSRQ
TDOSA, TDISA,
TCK, TMS, TRST
SDO3 25
DIGITAL AUDIO
PROCESSOR
IC612
DSD DECODER
IC801
9 XRST
XSRQ
62 DSBCKF
52 MCK
114 SDI3
D2
D0 – D15
MSDATO, MSDATI, MSCK,
XMSLAT, SHRRDY, SHRMUT
PHREFO 62
EXCKO1 13
F2SLR 45
(Page 34)
A0 – A15
11 MCKI
68 DSISR
SDO2 24
7-10, 13-16,
29-32, 35-38
N
768FS
DSARS 76
30 SDI2
Q
D1
5-1, 44-42,
27-24, 21-18
(Page 35)
LEVEL SHIFT
IC813
SDCK
XSAK
SDEF
XSHD
F2CSWEX2 46
D0 – D15
K
166
167
168
165
SDO1 23
108, 107, 105-102, 99
98, 80-77, 75-72
(Page 32)
XDCK
XSAK
SDEF
XSHD
67 DSISL
18 SDI1
A0 – A15
J
SDEF, XSHD,
XDCK, XSAK
DSALS 74
F2FLREX1 47
D1 – D4, SCK,
BCKO, LRCKO
D4
SDO4 26
112, 110, 109,
97-92, 82-85, 66-64
(Page 32)
LEVEL SHIFT
IC812
AV DATA BUS
DQ0 – DQ7
M
SD0 – SD7
66 DSISW
2, 3, 5, 6, 8,
9, 11, 12
(Page 32)
H
65 DSICT
A0 – A11
(Page 32)
DSAC 69
DSALFE 71
19-24, 27-32
E
64 DSIFR
139-136,
134-131
(Page 32)
DSAR 66
DQ0 – DQ7
C
123 WCK
A0 – A11
(Page 32)
63 DSIFL
162-159, 157-154,
152, 151, 149, 148
G
DSAL 64
126 WARFI
WCK
169 – 176
(Page 32)
A
SD0 – SD7
(Page 32)
127 WAVRB
WARFI
HCD-C770/C990
BLOCK DIAGRAM – AUDIO OUT, PANEL Section –
VIDEO 1
AUDIO OUT
P-MUTE
MUTING CONTROL
Q900
5 6
(Page 33)
S
(Page 33)
Q
OUTL2– 18
R
MUTING
Q207, 208
8 CDTI
7 CCLK
OUTL1– 21
RSTAD
NSMUTE
SCDT
SHIFT
LATCH1
INIT
PGMUTE
SYSTEM CONTROLLER
IC901 (2/3)
40 – 51
5 – 39
G1 – G12 S1 – S35
4 AD1
3 AD2
60
57
61
56
6 INA
OUTA
9
(+)
OUTB 19
(–)
OUTR2+
38
37
36
41
40
39
SCDT
SCSHIFT
SCLATCH
INIT
PGMUTE
NSPMUTE
D2
SCDT
SHIFT
LATCH2
INIT
PGMUTE
KEY0, KEY2
43 DATA
64 XFSIIN
44 BCK
45 LRCK
(+)
(–)
D102
D3
92 SIRCS
85 EN-A
86 EN-B
6 INA
OUTA
9
(+)
OUTB 19
(–)
OUTR2+
OUTL1+ 24
OUTL2+ 15
38
37
36
41
40
39
SCDT
SCSHIFT
SCLATCH
INIT
PGMUTE
NSPMUTE
DAMP-DATA
DAMP-CLK
CS1
CS2
CS3
DAMP-RST
DAMP-MUTING
1
2
29
30
31
26
27
OVER LOAD
DETECT
Q103, 104
D103
7 17 8 18
FSOI 74
XFSOUT 77
POWER AMP
IC306
6 INA
OUTA
9
(+)
16 INB
OUTB 19
(–)
D106
SCK
BCKO
LRCKO
SCDT
SHIFT
LATCH1
LATCH2
LATCH3
INIT
PGMUTE
SCDT
SHIFT
LATCH3
INIT
PGMUTE
POWER AMP
IC309
43 DATA
OUTL1+ 24
6 INA
OUTA
9
(+)
64 XFSIIN
44 BCK
45 LRCK
OUTL2+ 15
16 INB
OUTB 19
(–)
OUTR1+ 10
OUTR2+
38
37
36
41
40
39
SCDT
SCSHIFT
SCLATCH
INIT
PGMUTE
NSPMUTE
1
D104
7 17 8 18
REAR
L
OVER LOAD
DETECT
Q107, 108
FSOI 74
POWER AMP
IC311
6 INA
OUTA
9
(+)
16 INB
OUTB 19
(–)
REAR
R
ENA
ENB
DIAGA
DIAGB
7 17 8 18
4 CQ-RST
WOOFER
OVER LOAD
DETECT
Q111, 112
S201
3 I2C-DATA
5 I2C-CLK
100 I2HLP
CENTER
OVER LOAD
DETECT
Q105, 106
SCAN SELECT
I2CDATA
I2CCLK
I2HLP
FRONT
R
POWER AMP
IC307
STREAM PROCESSOR
IC310
49 PROG SW
V
9
OUTB 19
7 17 8 18
INTERLACE
(Page 35)
OUTA
16 INB
X1 39
SELECTABLE
ZIVARESET
6 INA
16 INB
1
XFSOIN 28
ROTARY
ENCODER
S800
POWER AMP
IC304
OUTR1+ 10
93 WAKE
VOLUME
W
BUFFER
IC300
OVER LOAD
DETECT
Q109, 110
XFSOUT 77
X2 38
REMOTE CONTROL
RECEIVER
IC101
(Page 35)
XFSOIN 28
X901
20MHz
DISC INSERT
DETECT
Q914
D105
7 17 8 18
FSOCKO 73
FSOI 74
FRONT
L
ENA
ENB
DIAGA
DIAGB
82 – 84
62 LED-CS
63 LED-CLR
KEY0 – KEY2
14-17, 1-4, 6, 7
P1 – P10
SCK
BCKO
LRCKO
SIRCS DETECT
Q906, 907
I2CDATA,
I2CCLK, I2HLP
1
XFSOIN 28
KEY INPUT
DETECT
IC903, 904
DISC IN
OUTR1+ 10
STREAM PROCESSOR
IC308
C818, R840
S801 – 805,
S811 – 825
J401
SPEAKER
16 INB
HP-SW
HP-MUTE
AU-MUTE
DAS-CS
64
46
47
32
LED DRIVER
IC801
D801 – 805
DISC1 – DISC5
32V
OUTL2+ 15
7 17 8 18
HPSW
HP-MUTE
AU-MUTE
DAS-CS
10
11
12
13
D192
OUTL1+ 24
OSC
DATA
CLK
STB
CLR
POWER ON
MUTING
Q192
64 XFSIIN
44 BCK
45 LRCK
FL-DATA
FL-CLK
FL-CS
FL-MUTE
OSC0 58
OSC1 59
D181
43 DATA
X300
49.152MHz
63
62
61
60
MUTING
Q900, 901
POWER AMP
IC301
D1
DAT
CLK
CS
RST
HP-SW
D180
D1 – D4, SCK,
BCKO, LRCKO
FLUORESCENT
INDICATOR TUBE
FL801
X
4
DAS-CS
FL DRIVER
IC802
(Page 36)
OUTR2–
MUTING
CONTROL
Q902
ENA
ENB
DIAGA
DIAGB
R
7
HADPHONE
AMP
IC401
AU-MUTE
SCK
BCKO
LRCKO
(Page 33)
OUTR1–
J900
PHONES
ENA
ENB
DIAGA
DIAGB
T
DIGDI
DIGCLK
AOUTR+ 10
AOUTR– 9
LOW-PASS
FILTER
IC610
ENA
ENB
DIAGA
DIAGB
(Page 33)
DIGDI, DIGCLK
1 MCLK
2 BICK
4 LRCK
STREAM PROCESSOR
IC305
J205 (2/4)
L
ENA
ENB
DIAGA
DIAGB
SCK
BCKO
LRCKO
AOUTL+ 12
AOUTL– 11
P-MUTE
3 SDTI
CSN
D4
: AUDIO
HP-MUTE
D/A CONVERTER
IC608
• SIGNAL PATH
PDN
7-3.
DIP-RST 43
D101
OVER LOAD
DETECT
Q101, 102
FAN
PROTECT DETECT
Q113, 114
DIP-OCP 44
34
34
Y
(Page 36)
HCD-C770/C990
7-4.
BLOCK DIAGRAM – VIDEO Section –
J205 (3/4)
• SIGNAL PATH
VIDEO 1
VIDEO IN
J206 (2/3)
F
XDCK, XSAK,
SDEF
XDCK
XSAK
SDEF
OUT 7
14 2B
OUT2 5
: COMPONENT VIDEO
VIDEO 1
VIDEO OUT
75Ω DRIVER
IC206
SW1
SW2
AV DATA BUS
177-174, 171-168
SD0 – SD7
: CHROMA
J205 (4/4)
1 IN1
3 IN2
5 IN3
VDAC_0 131
:Y
VIDEO SELECTOR
IC209
VIDEO AMP, 75Ω DRIVER
IC208
2 4
183 SDCLK
179 SDEN
182 SDERROR
VDAC_2 125
9 3B
OUT3 6
6 YIN
YOUT 28
VDAC_1 128
1 1B
OUT1 3
2 CIN
COUT 33
WIDE SWITCH
Q210, 214
4
CT2
CT3
CT1
(Page 32)
D
SDDATA0 – SDDATA7
VIDEO 2
VIDEO IN
(Page 32)
: VIDEO
VIDEO INPUT
SELECTOR
IC207
2
3
S VIDEO
1
J202
MONITOR OUT
12 7 2
(Page 32)
I
(Page 32)
L
(Page 33)
O
27M
139 XIN
XSRQ_ZIAV
4 VIN
VOUT 31
VIDEO
12 CYIN
CYOUT 25
Y
VDAC_3 122
14 CBIN
CBOUT 22
PB/CB
VDAC_4 119
16 CRIN
CROUT 19
PR/CR
178 SDREQ
SPDIF
156 IEC958
(Page 34)
V
ZIVARESET
202 RESET
MUTE1
MUTE2
J206 (3/3)
COMPONENT
VIDEO OUT
3 15
P
VS/WIDE
107
157
191
HAD0 – HAD15
22, 19-14, 11-3
HAD0 – HAD15
HA1 – HA3
2, 207, 206
190
195 27 25
MD0 – MD31
MA0 – MA12
42-33, 45, 46 48 47
57-60, 64-71, 75-78,
81-84, 88-95, 99-102
MCLK
MCS0
MWE
MRAS
MCAS
MDQM0
MDQM1
MDQM2
MDQM3
146 158
BA0
BA1
RST_SPC
188
HCS0
HREAD
WEN.UDS
CS_EEPROM
186 187 185 184
56 49 53 51 52 62 73 86 97
CE
OE
WE
HIRQ2
WC_EEPROM
161 160
DVD SYSTEM PROCESSOR
IC206
ALE
DRVRDY
106 I2C_CTRL
DRVTX
DRVRX
DRVCLK
HIRQ1
I2HLP
TDI
TDO
TCK
TMS
TRST
HA1 – HA3
1 8 3
55, 54, 52, 51,
49-47, 45-40, 38-36
1D1 – 1D10, 2D1 – 2D6
Q302
SWITCHING
IC802
34, 33, 31
2D7 – 2D9
1Q1 – 1Q10, 2Q1 – 2Q8
34 33 35 36
37
32
38
DRVRDY
CS ZIVA
RST
MECHANISM CONTROLLER
IC301 (2/2)
41
40
DATA & ADDRESS BUS
HAD0 – HAD15
15-22, 24-31
DQ0 – DQ15
HA1 –
HA3
11-9
2-8, 34-44
A0 – A2 A3 – A20
16Mbit PROGRAMMABLE ROM
IC204
X301
20MHz
35
35
DQ0 – DQ31
A0 – A11
12 14 1
22 23
68 20 17 19 18 16 71 28 59
CLK
CS
WE
RAS
CAS
DQM0
DQM1
DQM2
DQM3
21, 24-27,
60-66
128Mbit SD-RAM
IC202
BUS INTERFACE
IC215
ADDRESS BUS
HA4 –HA21
78 79
SOZIVA
SIZIVA
SCKZIVA
DRVIRQ
2, 3, 5, 6, 8-10, 12-17,
19-21, 23, 24
2,4,5,7,8,10,11,13,74,76,77,79,82,83,85,31,
33,34,36,37,39,40,42,45,47,48,50,51,53,54,56
56 29
CE
OE
WE
FLIP-FLOP
IC803
HA1 – HA3
CE
OE
WE
EEPROM
IC203
HAD0 – HAD15
1LE
2LE
6 DO
5 DI
4 SK
BS0
BS1
DATA & ADDRESS BUS
R/B
WC
CS
I2CDATA
I2CCLK
XTAL
I2HLP,
I2CDATA, I2CCLK
199
198
201
200
197
EXTAL
W
TDOSA
TDISA
TCK
TNS
TRST
I2C_DA
I2C_CL
(Page 34)
N
AV0 – AV2
AV2
AV0
AV1
I2C SIO
I2C-CLK
(Page 33)
TDOSA, TDISA,
TCK, TMS, TRST
(Page 33)
HCD-C770/C990
BLOCK DIAGRAM – CHANGER, POWER SUPPLY Section –
CHANGER CONTROLLER
(MOTOR, SWITCH)
IC902
STOCKER MOTOR DRIVE
IC721
M761
(STOCKER)
4 OUT1
2 OUT2
M
FIN 7
RIN 9
DC-DC
CONVERTER
T801
FL
FL1
20 P4
19 P5
TO FLUORESCENT
INDICATOR TUBE
RECT
D806 – 809
VFL
ROLLER MOTOR DRIVE
IC711
M781
(ROLLER)
4 OUT1
2 OUT2
M
OSC
Q803, 804
FIN 7
RIN 9
22 P2
21 P3
STREAM PROCESSOR
+3.3V
MODE MOTOR DRIVE
IC701
4 OUT1
2 OUT2
S716
S718
(Page 34)
In the midst disc is moving
between play position and stocker,
ON: disc is play position side,
OFF: disc is stocker side
S714 (DISC IN (8cm))
X
DISC IN
A3.3V
8 P12
+3.3V
REGULATOR
IC001
S715 (DISC OUT)
CHANGER CONTROLLER
(ROTARY ENCODER)
IC906
11 P9
S716 (STOCKER IN/OUT)
A5V, RF+5V
DA05V,
VIDEO +5V
+5V
REGULATOR
IC004
+5V
REGULATOR
IC002
9 P11
S717 (DISC POSITION)
ROTARY
ENCODER
S771
10 P10
S718 (STOCKING)
12 P8
OFF: In the midst disc is moving
between play position and
stocker
LEVEL SHIFT
Q731
D5V
ROTARY
ENCODER
S702
B+ SWITCH
Q003, 004
+32V
(AMP +32V)
DISC INSERT
DETECT SENSOR
IC751
+6.5V
REGULATOR
IC903
+6.5V
(AMP +6.5V)
(STOCKER POSITION)
79
PARA-DATA 72
PARA-CLK 71
PARA-LT1 69
+5V
REGULATOR
IC003
(MODE)
D/A, A/D
+5V
OPT-SEN
S717
7 P13
OFF: When disc out from
play position
OFF: The moment disc in/out
from stocker
+3.3V
REGULATOR
IC005
5 P15
S713 (DISC IN (8/12cm))
ON: Play position
(8cm disc only)
+5V
REGULATOR
IC302
+2.6V
REGULATOR
IC605
DA03V
5–8
S715
DSP +2.6V
S711 (DISC INSERT (8/12cm))
S713 (ON: Play position)
S714
23 P0
24 P1
P15 – P12
S711 (ON: When disc insert)
FIN 7
RIN 9
9 – 12
M
STREAM PROCESSOR
+5V
P11 – P8
M771
(MODE)
+3.3V
REGULATOR
IC303
26
3
4
2
DI1
CLK
LAT
RESET
DO1
DO2
CLKO
LATCHO
15
25
14
13
26
16
3
4
2
DI1
DI2
CLK
LAT
RESET
D202, 203
TU 10V
FAN MOTOR
CONTROL
Q190, 191
+10V
REGULATOR
IC601
10V
DO2 25
FAN
M12V
PARA-DO2 67
S901 (1/2)
S901 (2/2)
D900
D917
U5V
D901
SYSTEM
CONTROLLER
+5V
STOP 90
RESET SWITCH
Q901
RESET SIGNAL
GENERATOR
IC907
D812
STANDBY
+5.6V
REGULATOR
IC905
B+ SWITCH
Q990, 991
+2.5V
+2.5V
REGULATOR
IC702
+1.8V
+1.8V
REGULATOR
IC006
(AC IN)
TH901
LINE FILTER
LF901, 902
RECT
D902
VOLTAGE
DETECT
Q992
VOLTAGE DETECT
IC904
AND GATE
IC905
LED DRIVE
Q911, 912
POWER
TRANSFORMER
T901
D900
TU-ON 50
SP RELAY 66
POWER
+12V
REGULATOR
IC908
POWER ON/OFF
CONTROL
Q902, 906
POWER-SW 91
(Page 34)
B+ SWITCH
Q001, 002
12V
SYSTEM CONTROLLER
IC901 (3/3)
Y
B+ SWITCH
Q222, 223
PARA-RST 68
RESET 34
M301
(FAN)
M
+5V
REGULATOR
IC600
D919
D920
RECT
D911
3 D
D906
+6.8V
REGULATOR
Q904
+20V
REGULATOR
Q905
D933
4 VCC
1 OCP/SYNC
D905, 907
S901 (2/2)
POWER
U5V
D3.3V
S901 (1/2)
POWER ON/OFF
CONTROL
Q910, 911
DVD-POWER 89
P-PWM 11
ST-POWER 45
36
36
VCC
7-5.
+3.3V
REGULATOR
IC906
BUFFER
IC909
OSC
Q912, 914
SWITCHING
IC902
ISOLATOR
PC901
D912
POWER ON/OFF
CONTROL
Q901, 903
5 FB/OLP
POWER CONTROL
IC901
HCD-C770/C990
7-6.
• Circuit Boards Location
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
f
•
: internal component.
: Pattern from the side which enables seeing.
•
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Indication of transistor.
C
Q
These are omitted.
B E
Q
B C
E
These are omitted.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
•
: internal component.
• 2 : nonflammable resistor.
• C : panel designation.
Note:
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part
number specified.
video board
DDCON board
SEL board
power SW board
audio board
key board
Note:
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce por tant le numéro
spécifié.
not supplied
(power LED board)
• A : B+ Line.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : DVD PLAY
(
) : CD PLAY
[
] : SACD PLAY
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
J : CD PLAY
c : DVD PLAY
I : SACD PLAY
f : AUX IN
i : OPTICAL DEITAL IN
d : TUNER
F : AUDIO
L : VIDEO
E :Y
a : CHROMA
r : COMPONENT VIDEO
• Abbreviation
AUS : Australian model
CND : Canadian model
AMP board
FL board
power board
control board
DVD board
vol board
HP board
not supplied
(roller motor board)
stocker motor board
SW (4) board
SW (3) board
relay board
SW (2) board
SW (1) board
not supplied
(sensor board)
not supplied
(mode motor board)
37
37
RF board
HCD-C770/C990
7-7.
PRINTED WIRING BOARDS – RF Section –
1
2
3
• See page 37 for Circuit Boards Location.
4
5
6
7
8
10
11
12
13
RF BOARD (CONDUCTOR SIDE)
RF BOARD (COMPONENT SIDE)
A
9
FLEXIBLE BOARD
B
OPTICAL PICK-UP
BLOCK
(DVBU16)
E
E
C
64
D
49
1
48
IC001
A
16
DVD BOARD
CN401
E
33
17
32
(Page 42)
F
11
11
(11)
1-684-822-
1-684-822-
• Semiconductor
Location
Ref. No.
Location
D001
D002
C-11
B-11
IC001
D-11
Q001
Q002
B-3
B-3
38
38
(11)
HCD-C770/C990
SCHEMATIC DIAGRAM – RF Section –
• See page 71 for Waveforms.
• See page 76 for IC Block Diagram.
RFMON
C028
0.1
C025
0.1
R023
820
C027
0.1
C030
C026
0.1
C031
1000p
C006
22
10V
R026
12k
C013
0.1
AGND
C029
0.01
RFAC
C035
0.1
C024
0.01
JL005
CN002
29P
0.01
AGND
AVC
R024
0
AVC
C022 22p
D
C023 22p
D
MIRR
MIRR
C018 5600p
C020 22p
CN001
24P
C021 22p
JL004
PI/CE
PI
TE
TE
FE
FE
C
C
JL007
RFP
RF
C009
0.1
GND
A5V
R025
100
RFP
A5V
SDEN
C019
5600p
R022
220
SDEN
R027 0
SDEN
R028 0
DATA_RF
R029 0
CLK_RF
DATA_RF
DATA_RF
VC
C017
2200p
VCC
FLEXIBLE
CLK_RF
CLK_RF
E
A
A
B
B
C
C015 2200p
F
D
C014 2200p
LDON
LDON
E
BOARD
C016
2200p
A3V
A
RFMON
B
RFMON
C032
0.047
F
C033
0.1
JL006
N.C
R001 100
(Page 44)
INLIM
LDSEL
C042
180p
PD
PD
C005
22
10V
C012
0.1
JL003
CD/DVD/SACD RF AMP,
R014 0
VR
FD-
R032
100
FDFE
FD+
TE
TD-
PI/CE
TD+
FD+
FOCUS/TRACKING ERROR AMP
R013 0
IC001
CXD1881AR
VCC
R012 0
TDTD+
SW
R011 0
SLB-
R018 0
SLB+
SLEDB-
LD GND
DVD_LD
SLEDB+
DVD LD
R017 0
C049
0.1
INLIM
R016 0
CD_LD
CD LD
SLASLEDASLA+
JL002
SLEDA+
JL001
SPDL-
R015 0
INLIM_3V
FD+
SPDL+
FCS+
FDFCSTD+
TRK+
TDTRK-
R041
1k
R020
0
C008
0.1
C041
0.1
LDON
R021
0
330p
R033
0
C036
0.47
R034
10M
C034
0.1
MIRR
R019
0
C037
C039 0.033
F
C038 0.033
R035
0
E
C040
0.1
PD
7-8.
CD_LD
R003
33
R004
33
R005
47k
C001
100
6.3V
R007
33
R006
470
R008
33
R009
47k
C003
100
6.3V
R010
470
IOP1
IOP2
Q001
2SB1132-T100-QR
Q002
2SB1132-T100-QR
AUTOMATIC POWER
AUTOMATIC POWER
CONTROL
CONTROL
(FOR DVD)
(FOR CD)
DVD_LD
CN003
9P
SLB+
SLEDB+
SLB-
D001
1SS355TE
-17
C002
10
16V
C011
1000p
L002
47µH
L001
47µH
SLA+
SLEDA+
C010
1000p
D002
1SS355TE
-17
C004
10
16V
SLEDBSLASLEDALED {LIMIT-SW(A)}
GND {LIMIT-SW(B)}
INLIM {LIMIT-SW(B)}
SPDLSPDL+
Replace only with part number specified.
39
39
Les composants identifiés par une marque 0 sont
critiques pour la sécurité. Ne les remplacer que
par une pièce portant le numéro spécifié.
HCD-C770/C990
7-9. PRINTED WIRING BOARDS – CHANGER Section – • See page 37 for Circuit Boards Location.
1
2
3
4
5
5
6
7
6
8
5
6
1
A
RELAY BOARD
SW (4) BOARD
STOCKER MOTOR BOARD
2
4
1
4
2
1
3
4
1
4
M
B
1-685-011-
(11)
1-685-006-
1
11
S716 (STOCKER IN/OUT)
11
(STOCKER)
(11)
3
OFF: The moment disc in/out
from stocker
2
1
S717 (DISC POSITION)
In the midst disc is moving between
play position and stocker,
ON: disc is play position side,
OFF: disc is stocker side
3
2
1
MODE MOTOR BOARD
S718 (STOCKING)
OFF: In the midst disc is moving between
play position and stocker
7
C
SW (3) BOARD
3
M
2
1
(DISC OUT)
1-685-010-
S715
OFF: When disc out
from play position
ROTARY ENCODER
(STOCKER POSITION)
4
3
G
2
1
11
(11)
SW (2) BOARD
1
9
ROTARY ENCODER
(MODE)
3
2
(DISC IN (8cm))
1-685-009-
1
S714
(ON: Play position (8cm disc only))
11
DVD BOARD
CN006
(11)
(Page 42)
11
IC701
1
S713
(DISC IN (8/12cm))
(ON: Play position)
9
IC721
2
M
E
(ROLLER)
3
1
1
11
9
2
1
(DISC INSERT (8/12cm))
(ON: When disc insert)
1-685-008-
F
• Semiconductor
Location
Ref. No.
Location
D701
D711
D721
D-5
E-6
E-5
IC701
IC711
IC721
IC751
D-5
E-5
D-5
F-4
Q731
E-4
(11)
ROLLER MOTOR BOARD
SW (1) BOARD
E
1 2 G 3 4
1-685-005-
B
D
(MODE)
1
IC711
11
(11)
SENSOR BOARD
3
1
E
K
C
A
1-685-01211
(11)
IC751
DISC INSERT
DETECT SENSOR
1-685-004-
40
11
(11)
40
1
1-685-007- (11)
1
HCD-C770/C990
7-10. SCHEMATIC DIAGRAM – CHANGER Section –
CNP751
3P
DIODE
D SENSE
GND
• See page 76 for IC Block Diagrams.
CN702
3P
R731
150
DIODE
D SENSE
R733
10k
GND
CN701
28P
R734
15k
IC751
RPR-220
D+5V
R732
1k
GND
M+12V
Q731
RT1N141
RIN
VCC
FIN
OUT1
VM
OUT2
RNF
VREF
DISC INSERT
DETECT SENSOR
MODE MOTOR
M+12V
MGND
LEVEL
DRIVE
SHIFT
MGND
P81 D.SENSOR
IC701
BA6956AN
C754
0.1
C711
10
50V
R701
680
D701
MTZJ-T-77-4.7B
P41 SW1-B
SW2A
P42 SW2-A
SW2B
P43 SW2-B
C751
0.1
SW4
P93 SW4
P94 SW5-A
SW5A
P44 LOD POS
CN703
2P
MTR RL 1
MTR RL 2
MTR RL 2
MTR RL 1
C781
0.01
P45 LOD NEG
RIN
GND
VCC
FIN
VM
RNF
(ROLLER)
OUT1
VREF
P46 SLD POS
OUT2
M781
SW1B
C756
0.1
C752
0.1
CNP781
2P
P40 SW1-A
SW1A
C755
0.1
R702
100
P92 SW3
SW3
C758
0.1
P47 SLD NEG
ROLLER MOTOR
P90 ELV POS
(Page 52)
DRIVE
P91 ELV NEG
P95 SW5-B
GND
RIN
VCC
FIN
VM
RNF
OUT1
VREF
OUT2
SW5B
IC711
BA6956AN
C753
0.1
STOCKER MOTOR
P03 SLD E2
IC721
BA6956AN
CNP761
2P
M761
CN704
2P
MTR ST 2
MTR ST 2
MTR ST 1
MTR ST 1
C761 R722
0.01
100
P96 SLD E0
P02 SLD E1
R712
100
DRIVE
P04 SLD E3
C765
0.1
D711
MTZJ-T-77-5.1A
R711
680
P82 ELV E0
P83 ELV E1
C764
0.1
P54 ELV E2
C763
0.1
P55 ELV E3
(STOCKER)
D721
MTZJ-T-77-3.6A
C762
0.1
R721
680
S702
ROTARY ENCODER
(STOCKER POSITION)
CNP711
3P
GND
S711
CNP705
3P
GND
SW1-A
SW1-A
SW1A
SW1-B
SW1-B
SW1B
(DISC INSERT(8/12cm))
(ON:WHEN DISC INSERT)
CNP721
3P
GND
S713
CNP706
3P
GND
SW2-A
SW2-A
SW2A
SW2-B
SW2-B
SW2B
(DISC IN(8/12cm))
(ON:PLAY POSITION)
S714
(DISC IN(8cm))
(ON:PLAY POSITION(8cm DISC ONLY))
S771
ROTARY ENCODER
(MODE)
CNP731
2P
CNP707
2P
GND
GND
SW3
SW3
CN710
7P
C769
0.1
SW3
S715
(DISC OUT)
C768
0.1
CNP771
7P
E1
E1
E2
E2
GND
C767 0.1
E3
C766 0.1
E4
GND
E3
(ON:WHEN DISC OUT FROM PLAY POSITION)
CNP741
4P
S716
(STOCKER IN/OUT)
CNP708
4P
GND
GND
SW4
SW4
MTR MD 1
MTR MD 2
MTR MD 2
C771
0.01
SW4
SW5-A
SW5-A
SW5A
SW5-B
SW5-B
SW5B
ON:THE MOMENT DISC IN/OUT
FROM STOCKER
S717
(DISC POSITION)
IN THE MIDST DISC IS MOVING
BETWEEN PLAY POSITION AND STOCKER,
ON:DISC IS PLAY POSITION SIDE,
OFF:DISC IS STOCKER SIDE
S718
(STOCKING)
OFF:IN THE MIDST DISC IS MOVING
BETWEEN PLAY POSITION AND STOCKER
41
E4
MTR MD 1
41
M771
(MODE)
HCD-C770/C990
7-11. PRINTED WIRING BOARD – DVD Board (Component Side) –
• Semiconductor
Location
Ref. No.
1
2
Location
D900
D901
C-2
C-6
IC206
IC301
IC401
IC402
IC605
IC606
IC607
IC612
IC701
IC801
IC813
IC901
IC902
G-9
E-3
G-4
G-2
E-14
E-12
C-13
C-11
G-6
C-8
D-7
C-3
C-6
Q914
C-5
3
4
5
6
B
DVD BOARD (COMPONENT SIDE)
A
7
RELAY BOARD
CN701
8
9
10
11
12
13
14
15
(Page 40)
B
132
89
133
88
IC612
IC902
C
IC901
IC607
G
C
IC801
E
DDCON
BOARD
CN814
AMP
BOARD
CN301
(Page 55)
(Page 62)
D
IC813
176
45
3
1
25
1
24
13
25
25
12
D
IC605
AMP
BOARD
CN305
100
IC606
NC
E
IC301
36
52
50
44
76
45
51
(Page 55)
48
1
53
1
2
1
37
F
1
44
208
176
75
7
NC
IC206
IC701
G
1
H
POWER
BOARD
CN903
IC402
(Page 69)
NC
IC401
88
133
89
104
132
157
105
156
H
I
1-685-086-
A
RF BOARD
CN002
F
VIDEO BOARD
CN203
(Page 60)
(Page 38)
42
42
E
AUDIO BOARD
CN202
(Page 58)
11
HCD-C770/C990
7-12. PRINTED WIRING BOARD – DVD Board (Conductor Side) –
1
A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
DVD BOARD (CONDUCTOR SIDE)
E
B
E
E
E
E
E
E
IC905
4
3
E
5
IC906
IC900
C
IC702
11
E
3
E
2
1
3
1
IC903
1
+
IC005
1
1
(C990)
E
20
3
D
3
5
IC907
IC808
2
4
1
(US, CND)
4
10
5 4
IC812
3
5
IC904
(EXCEPT AEP)
IC604
E
1
IC302
IC303
2
56
E
16
8
9
29
IC004
1
1
3
IC215
1
1
1
8
4
5
IC814
28
1
IC602
IC608
IC600
1
16
8
9
5
5
3
4
IC803
E
3
IC706
IC204
IC601
1
3
IC003
IC610
2
G
1
IC802
2
F
8
4
2
IC202
IC203
3
E
1
2
E
IC002
E
H
1
IC603
E
E
3
IC501
1
2
3
IC703
IC001
3
1
IC006
I
1-685-086(AEP)
2
11
43
43
• Semiconductor
Location
Ref. No.
Location
D902
D903
D904
D906
D907
C-13
C-11
C-13
C-12
B-14
IC001
IC002
IC003
IC004
IC005
IC006
IC202
IC203
IC204
IC215
IC302
IC303
IC501
IC600
IC601
IC602
IC603
IC604
IC608
IC610
IC702
IC703
IC706
IC802
IC803
IC808
IC812
IC814
IC900
IC903
IC904
IC906
H-5
H-4
G-4
E-2
D-2
I-6
G-8
G-5
G-7
E-6
D-14
E-8
H-13
F-2
G-3
F-4
H-3
C-4
F-3
G-3
D-6
H-9
F-10
E-12
E-12
C-8
D-10
E-9
C-5
D-12
D-13
C-10
Q001
Q002
Q003
Q004
Q301
Q302
Q900
Q901
Q902
Q903
Q906
Q907
Q908
Q909
Q910
Q911
Q912
Q913
H-2
I-2
H-3
I-3
F-12
G-5
B-13
B-13
B-13
D-11
C-12
D-12
B-6
B-6
B-5
B-14
B-14
B-12
HCD-C770/C990
7-13. SCHEMATIC DIAGRAM – DVD Board (1/10) –
A5V
D5V
DGND
A3.3V
D3.3V
AVC
(Page 47)
(1/10)
A5V
A3.3V
DGND
D5V
D3.3V
AVC
(Page 53)
M12V
MGND
SPIN
C401
0.1
CN401
29P
C514
0.01
SPDL+
GND
R533 R534
56k
33k
VCC
SLEDA
AGND
RFAC
R532
0
JL535
SLEDB+
SLEDB
MIRR
MIRR
JL531
PI
JL530
TE
JL529
FE
R530 R531
56k
0
PI
SLEDASDEN
DATA_RF
JL524
CLK_RF
C510
1000p
DATA_RF
TFDR
TRK+
LDON
JL522
R524
10k
TRKJL501
RFMON
R437
47k
XLAT
DATA
MUTE_CD
XRST_CD
R407 0
R408 0
R410 0
CLOK
R409 0
SCLK
SENS
R405 0
R406 0
WFCK
C2PO
SCOR
R424
0
FCS+
R423 1k
TFDR
TRDR
R425 1k
C412 0.0022
FFDR
FRDR
C413 0.0022
R426 1k
DIGITAL SERVO PROCESSOR
R429 1k
IC401
CXD3068Q
R427 0
R431
0
R430 1k
R435 0
R523
10k
R438 0
FE
FD+
JL509
TRK-
JL510
TRK+
JL503
SLEDB-
R520
10k
TD-
FE
R443
47k
SLEDB-
R521
100k
SLEDB+
SLEDB+
JL505
SLEDA-
JL506
SLEDA+
SLEDA-
FJMP2
FJMP1
SLEDA+
JL507
SPDL-
JL508
SPDL+
R519
100k
R416
0
SPDLFCS-
TE
TE
C504
33000p
SPDL+
R415
0
R512
56k
C506
330p
R517
2.2k
R442
10k
(Page
45)
R445
1k
PI
R450
1k
R516
4.7k
R510
150k
RFAC
RFAC
C529
0.1
R428
1k
C418
0.1
C528
22
16V
R554
0
R455
100k
SPFG
R511
150k
MD2
PI
C508
1000p
R536
200k
C503
33000p
CDDOUT
FFDR
TD+
JL504
LRCK
R439 330
R441
1k
C428 2200p
R522
4.7k
C426
0.01
R446
10k
R448
1k
C432 100p
(CH12)
R447 10k
FCS+
R449 33k
FCS-
JL512
BCLK
R436 0
C425
0.0022
LDSEL
JL511
FD-
C419 0.047
JL500
LDSEL
768FS
DIGITAL SIGNAL PROCESSOR,
FRDR
INLIM
R513
56k
(Page
39)
INLIM
R421 1k
R432 0 MDAT
C509
330p
RFMON
JL502
C408 0.1
R440
47k
C409 0.0022
R527 R525
10k
2.2k
TRDR
SLED
LDON
SQSO
C407 10
VOLTAGE
GENERATOR
CLK_RF
JL523
SQCK
R420 0
SLEDA+
SDEN
A3V
R417 0
REFERENCE
R433
47k
A5V
JL525
AMP,
R528
0
JL527
JL526
R434
47k
C414
0.01
FE
EXCK
SBSO
R451 10k
MDP
TE
A5V
R413
10k
SLEDCTRL
C420 0.0022
C406
0.0022
R529
33k
C424
0.022
AVC
C512
0.01
C416 10
AVC
C417 0.1
SLEDBC405
10 16V
R412
10k
C411
0.1
R535 0
SPDL-
AGND
JL536
SPC970_BUS
R403
0
R411
0
SLEDCTRL
RFAC
C415 0.01
JL537
R402
0
IC402
NJM3404AV(TE2)
R579
8.2k
R404 0
IC501
FAN8035
R401 0
C410
10
16V
SPINDLE/SLED MOTOR DRIVER
(CH3456)
GSCOR
LOCK
WAVRB
FOCUS/TRACKING COIL DRIVER,
COUT
DSP_BUS
C519
0.01
JL544
C402
10
R419
68k
C404
0.1
MIRR
R418
10k
FOK
R580
33k
DFCT
R582 R583
10k 10k
R581
12k
GFS_CD
MUTE_2D
C526
22
16V
SP_ON
C527
0.1
TSD-M
FL401
C427
0.47
C433
0.0015
R444
470k
C421
0.1
R457
3.3k
R452
1M
C422
100p
FL402
C423
0.1
R453
1M
C434
10
C436
0.1
C435
0.1
R598
0
R553
0
C525
0.1
ANALOG_BUS
44
44
HCD-C770/C990
(2/10)
D1
D2
RF_AC
JITOFF
R545
100k
R544
100k
TP702
R540
10k
C703
0.1
R729
8.2k
C715
1500p
BUFFER
6
(1/2)
R726
100k
TP701
COMPARATOR
R724
1k
R541
100k
MDIN
5
8
R727
3.3k
2
1
C718
0.1
C721
0.1
R728
10k
C728
0.1
C722 0.1
C723
0.1
D3
GFS_DVD
MA8
MA9
XMOE
BD9
BD8
BDA
BDF
R719 1k
XCAS
D4
BDC
R715 10k
IC703(1/2)
NJM3404AV(TE2)
R718
10k
R709
68k
SPIN
4
BDB
R708
1M
R747
33k
C720
0.1
BDE
R707
100
C706
0.1
R714
10k
R721
33k
BDD
C702
10
R711
2.2k
R781
0
R720
1k
R780 0
C752
0.1
R712
10k
C717
0.01
R717 100k
FL701
C729
10
C711
0.01
C716
0.47
R716 100
R710
10k
C709
0.1
FL706
A5V
C714 0.1
C708
0.001
R713 10k
R538
100k
C521
1500p
IC703(2/2)
NJM3404AV(TE2)
MDP
C713 0.1
3
C712 220p
7
R725
1.8k
R748
33k
(2/2)
C523
1500p
JIT
AVC
R772
22
D5
D3V
D5V
FL703
C780
10
DGND
C777
0.1
C778
0.1
FL702
A3V
C730
0.1
C779
10
FL704
C781
10
C776
0.1
R771
2.2k
MA7
C770
0.1
AGND
MA6
C775
0.1
MA5
MDIN
MA4
R765 22k
R767
47k
C772
0.1
C774
0.0047
R764
1M
C773
0.47
C771
0.047
R762
22k
MA3
MA2
ANALOG_BUS
MA1
R763
8.2k
MA0
R730 22
RAS
R731 22
R770
0
WE
GSCOR
R759 0
EXCK
R758 0
BD6
SBSO
R757 0
BD5
SCOR
R756 0
WFCK
R766 0
BD7
BD4
(Page 46)
BD3
BD2
BD1
R755
0
BD0
DVD DECODER
BCLK
R754
0
C769
0.1
R753
0
C768
0.1
R732 10k
IC701
CXD1882R
DSP_BUS
C742
0.1
MDAT
R702 10k
R703 10k
R752
0
LRCK
C766 100p
R735 10k
R704 10k
R799
0
R737 10k
R776
0
R705 10k
C765
0.1
SPC970_BUS
C743
0.1
C744
0.1
C745
0.1
XSRQ
R750
10k
R706 10k
D0
R741 22
XSHD
D1
R742 22
XDCK
D2
XSAK
D3
D4
R743
22
SD0
SD1
SD2
SD3
SD4
SD5
R744 22
SDEF
SD6
SD7
XINIT0
R745
47k
XINIT1
XHRD
XHWR
XCS1882
A7
A6
A4
A5
A2
A3
A1
D7
A0
D5
D6
R777
0
D6
D7
R746 47k
C760 0.1
C763 0.1
C764 0.1
C762 0.1
C761 0.1
(Page 47)
45
45
E6
E7
E5
E4
E3
E1
D8
E2
(Page 44)
C741
0.1
C767
0.1
R778
100k
C2PO
C740
0.1
HCD-C770/C990
(3/10)
D1
DGND
D3V
DGND
RF_AC
C870
33000p
WAVRB
R804
0
D3V
AGND
D3V
D2
FL811
R803
100
WPK
D3
WRF
SL812
C871
0.01
R844 0
R845 0
R846 0
R834 0
R833 0
R835 0
R836 0
R837 0
R838 0
DQ7
DQ6
MA3
MA2
DSLS
IFRM
IEMPTY
VDIOB0
IBCK
IOUTE
VSCB1
IERR
IANCI
IPLAN
IHOLD
VDCB1
IVLD
IDIN0
IDIN1
IDIN2
IDIN3
IDIN4
IDIN5
VSIOB1
IDIN7
WAD1
WAD0
VDIOB1
TESTI
WAD2
WAD3
WAD4
VSCB2
WAD7
WAD6
WAD5
VDCB2
WCK
WRFD
WAVDD0
WARFI
DQ5
WAVDD1
DQ5
WAVRB
WAVSS0
C726
0.1
VSIOA2
DQ6
C725
0.1
WAVSS1
SDATALS
DQ7
MA1
MA10
MA11
MA0
RAS
WE
BD7
BD6
BD5
BD4
R840 0
R843 0
WPK
IC706
MSM51V18165F60TSKR1
R841 0
A4
VDD
A3
A2
A1
A0
A10
A11
RAS
WE
N.C.
N.C.
N.C.
I/O7
I/O4
VDD
VDD
BD3
BD2
BD1
BD0
C724
0.1
C866
0.01
R852
0
16Mbit D-RAM
WRF
C727
10
C865
0.01
R842
10k
R805
10k
D5
FL705
C867
0.01
SL811
GND
A6
A7
A5
A9
A8
OE
UCAS
N.C.
LCAS
N.C.
I/O9
I/O8
I/O6
I/O11
I/O10
I/O5
I/O12
I/O3
GND
I/O13
I/O2
I/O14
I/O1
GND
I/O15
I/O0
SL813
C815
0.01
IDIN6
MA6
MA5
MA4
MA9
MA8
MA7
XCAS
XMOE
BD9
BD8
BDA
BDB
BDC
BDF
BDD
BDE
D4
DSRS
SDATARS
R851
0
DSL
SDATAL
DSR
IFULL
SDATAR
DQ4
DSC
IANCO
DQ4
SDATAC
DSLF
C842 0.01
SDATALF
IOUT5
DQ3
SA4
SA5
SA6
SA8
SA9
DCKE
SA7
DQ3
DCLK
R882 10k
R883 10k
R884 10k
R885 10k
R886 10k
R887 10k
R888 10k
R889 10k
VSIOB0
VDIOA2
C849
0.01
DQ2
DQ2
IOUT4
DQ1
VDCB0
DQ0
IOUT3
DQ1
DQ0
+2.5V
REGULATOR
IOUT2
DCLK
VSCB0
VSS
A4
A5
A6
A7
A8
A9
NC
CKE
CLK
UDQM
IOUT1
DCKE
SWE
XWE
IOUT0
XCAS
VDDSD1
VDD
A3
A2
A1
A0
A10/AP
A11-BA
CS
RAS
CAS
C837
0.01
SRAS
DSRS
DSARS
XRAS
VDIOA3
ZDFRS
NC
DSALS
SA11
C797
220
4V
A11
ZDFLS
A10
VSDSD1
VSCA3
DSALFE
A9
ZDFLFE
A8
DSAC
VDCA3
ZDFC
SA3
SA2
SA1
SA0
SA10
SA9
SA8
FL810
C840
10
C843
0.01
C854
0.01
C804
0.01
SA7
A7
R850
22
(Page 50)
C811
0.01
A5
ZDFR
A4
DSAL
VSIOA4
ZDFL
SA3
A3
PHREFO
A2
PHREFI
A1
BCKAO
A0
BCKAI
SA2
SD7
XSAK
SDEF
SD6
AV7
XSHD
XSAK
SD5
AV6
XDCK
XSHD
SD4
AV5
SDCK
SD3
AV4
SD2
AV3
SA1
C819
0.01
R849
22
DSC
C855
0.01
R848
22
DSAR
IC801
CXD2752R
A6
SDEF
C861
0.01
DSR
SA4
IC812
SN74LV245APWR
C812
0.01
DSLS
VDDSD0
DSD DECODER
SA6
SA5
IC813
SN74LV245APWR
R826
22
DSLF
SA11
SRAS
SCAS
SWE
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
SA10
DQ0
(Page
45)
C857
0.01
SCAS
WE
DQ8
VDDQ
VDDQ
DQ7
DQ6
LDQM
NC/RFU
DQ9
VSSQ
VSSQ
DQ11
VDDQ
DQ10
DQ5
DQ4
VDDQ
VSSQ
DQ12
DQ13
DQ3
DQ2
DQ1
IC808
MSM56V16160F-8TK
7R1
VDD
OUT
VSSQ
16Mbit SD-RAM
G
DQ14
DQ15
VSS
DCKE
IN
C796
0.1
VSIOA3
DCLK
IC702
TA48M025F(TE16L)
DQ0
C795
100
6.3V
R821
22
DSL
R822
22
DSBC
R823
22
DSMCK
CDDOUT
SA0
R830 4.7k
VDIOA4
VSDSD0
XSRQ
BCKASL
XSHD
NC
SDCK
NC
XSAK
VDCA2
XSHD
SD1
AV2
SDCK
SD0
AV1
XSAK
AV0
SDEF
NC
SDEF
AV0
R867
0
C856
0.01
R866
0
TEST5
SD0
AV1
TEST4
SD1
AV2
SACD/DVD
SELECT
AV5
SD4
SUPEN
SD5
SUPDT7
SD6
SUPDT6
SUPDT5
SUPDT4
VSIOA1
SUPDT3
SUPDT2
SUPDT1
SUPDT0
XBIT
TEST3
UBIT
VDCA1
TEST2
TEST1
TRST
TMS
TDO
VSCA1
TDI
TCK
MNT7
MNT6
MNT5
MNT4
MNT3
MNT2
MNT1
MNT0
F75HZ
VDIOA0
EXCKO2
VDIOA1
LRCK
EXCKO1
VSIOA0
A
MCKI
VCC
SMUTE
B
XRST
ST
MSREADY
AV7
XMSLAT
Y
VSCA0
SL
XMSDOE
GND
SD7
C848
0.01
R865
0
AV6
Y
C803
0.01
FL812
R829 100
C813
0.01
TRST
C810
0.01
SHRMUT
XRST_DSD
SHRRDY
XMSLAT
C807
0.01
R827
100
MSDATO
C808
100p
D7
MSDATI
D6
MSCK
C841
10
IC814
TC7WH157FK
AV4
MSDATI
XSRQ
C802
10
VSCA2
MSDATO
R847
22
NC
SD3
VDCA0
FL807
SD2
AV3
LEVEL SHIFT
MSCK
LEVEL SHIFT
TMS
R831
33k
TDOSA
TDISA
TCK
(Page 48)
R828 4.7k
C817
0.01
C818
0.01
R800
4.7k
D8
F7
F6
F4
F3
F2
F1
768FS
(Page 47)
46
46
C839
0.01
C838
0.01
CDDOUT
R839 4.7k
HCD-C770/C990
F6
F7
F3
F4
F1
F2
(Page 46)
(4/10)
E7
E5
E6
C320
0.01
C301
10
10V
C303
0.01
C302
0.01
R305
10k
XSRQ_ZIVA
FL301
XRST_DSD
JIG_MOD
DRVCLK
DRVRDY
I2C_SIO
CS_SPC
27M
I2C_SCL
RXD
TXD
R308 22
XHWR
CLK_RF
R307 22
XHRD
DATA_RF
R304
22
R306 22
A0
A1
A2
A3
A5
A4
A6
A7
DSAVE
XRST_CD
XRST_DVD
SDEN
A2
A1
A0
VCC
WP
IC302
BR24C02F-WE2
SCL
EEPROM
SDA GND
ZIVA_BUS
LDSEL
(Page 48)
SWITCHING
IC802
TC7S32FU(TE85R)
Q301
DTC114EKA
-T146
VCC
LASER DIODE
SELECT
GND
R303
22
R312
10k
(Page 45)
E2
LDSEL
FLIP-FLOP
R738
22
E1
IC803
TC7W74FK(TE85L)
LOCK
R352 0
FOK
R351 0
R309
MD2 0
TSD-M
TSD-M
SCLK
R350 100
R311
22
GFS_CD
R349 0
FL304
R313 0
FJMP2
R314 0
SENS
R315 0
C309 C310
100p 100p
C311
0.01
IC303
IMIC6007BT-D
R346 1k
R345 0
R344 1k
CLOCK
PI
VDD1
NC
TE
VSS1
NC
JIT
XCS1882
E4
SP_ON
R342 0
MECHANISM
D0
CONTROLLER
D1
IC301
CXP973064-220R
C308
MO1
CL301
R355
22
NC
33000p
SLED
R340 0
NC
MUTE_2D
R339 0
MUTE_CD
D3
D4
GFS_DVD
R338 0
D5
R332 10k
D6
R333 10k
D7
XINIT0
C317
15p
X302
27MHz
R362
390
R354
1M
GENERATOR
R356
68
SO3
VDD2
VDD3
VSS2
VSS3
C318 12p
D2
R361 10k
FE
XTI
SO2
XTO
SO1
CL304
R357
68
CL303
E3
FJMP1
R358
68
CL302
R316 10k
C312 10 10V
SPFG
R363
10k
R341
0
R337 100
C316
10 16V
SQCK
SHRMUT
XINIT1
MSCK
R336 0
R335 22
C313
0.1
SQSO
XMSLAT
L301
10µH
FL303
CN301
7P
RFMON
JL301
RF_AC
JL302
RF
C307
0.01
RF_AC
JL303
GND
TXD
JL304
RXD
JL305
R329 100
R330 100
R326 100
R327 100
R328 100
MSDATO
DGND
MSDATI
C304 0.01
R323 100
R322 0
R321 100
R320 0
R319 0
R317 100
AVC
AVC
R318 100
TXD
RST_SPC
R331
220
D3V
DGND
JL307
3V-D
R353
10k
D5V
(Page 44)
R360
10k
CLOK
DATA
SHRRDY
JITOFF
SLEDB
X301
20MHz
SLEDA
DRVIRQ
DRVCLK
DRVTX
DRVRX
CS_SPC
INLIM
COUT
MIRR
LDON
XLAT
C791
100
6.3V
SCOR
D5V
C793
220
4V
RXD
JL306
R364
4.7k
R324
0
D3.3V
C809
0.01
DGND
A3V
A3.3V
A5V
A5V
AGND
47
47
R359
10k
(FOR CHECK)
HCD-C770/C990
DA05V
DGND
(Page 53)
(5/10)
VS
I/P-SW
R234 75
R261 0
R210 75
R266 75
R260 0
CR/B
R265 75
R259 0
R209 75
R264 75
CB/R
FB004
R258 0
R015 0
TP025
CB/R
Y
R263 75
TP024
GND
C
R208 75
CR/B
R257 0
R013 0
CR
R262 75
SPDIF
R064 0
TP023
I/P SW
R207 75
V
I/P-SW
TP076
I2C_CTRL
TP077
NC
CB
D5V
C201
220
4V
C225
0.1
FB202
C229
0.01
R236
1k
C230
0.01
C231
0.01
C232
0.01
C233
0.01
D5V
GND
TP026
R036 0
Y
(Page 61)
TP027
R039 0
C
TP028
R041 0
V
TP029
R043 0
VS
R203
180
R232
0
VIDEOY
R206
0
G1
R249 R250
4.7k 4.7k
VIDEOC
FB201
GND
R245
4.7k
C236
0.01
C235
0.01
C237
0.01
G2
G3
GND
R238
100
VIDEOV
R246
4.7k
VS/WIDE
CN003
14P
(Page 50)
SPDIF
SPDIF
(Page 52)
27M
ZIVARESET
I2C_SCL
R253
4.7k
C240
0.01
R252
4.7k
I2C_SIO
I2C_CTRL
I2C_CTRL
MD31
I2C_SCL
ZIVA_BUS
R233
10k
CS_SPC
CN201
4P
(Page 47)
MD30
I2C_SIO
MD29
MD28
C241
0.01
RXD
MDQM3
TXD
(FOR CHECK)
R248
4.7k
GND
MD27
D5V
MD26
C228
0.01
SD7
MD25
SD6
MD24
MD23
SD5
R239
47k
MD22
SD4
MD21
R202
0
MD20
SD3
C246
0.01
SD2
C247
0.01
MDQM2
SD1
MD19
SD0
Q302
DTC114EKA
-T146
INVERTER
XSRQ_ZIVA
MD18
XSAK
MD17
MD16
EEPROM
IC203
BR9040F
C251
0.01
SDEF
MD15
XDCK
DVD SYSTEM PROCESSOR
R/ B
VCC
C255
0.01
DRVIRQ
WC
GND
DRVCLK
CS
DO
DRVTX
SK
DI
DRVRX
R226
4.7k
MD14
IC206
ZIVA-5P-B0
MD13
MD12
C252
0.01
MDQM1
DRVRDY
(Page
49)
R247
4.7k
ALE
MD11
RST_SPC
MD10
MD9
MD8
C264
10
C243
0.01
C250
0.01
C259
0.01
MD7
C203
0.01
MD6
MD5
TRST
CL201
TDISA
CL202
TDOSA
CL203
TMS
CL204
TCK
CL205
MD4
MD3
MD2
SYS_RST
CL206
R235
0
C260
0.01
MDQM0
MD1
TDOSA
TDOSA
MD0
R243
10k
MCLK
TRST
C261
0.01
TRST
TDISA
TDISA
HA3
R229 33
HA2
R230 33
R212 22
R242
10k
C262
0.01
MWE
TMS
(Page 46)
TMS
TCK
TCK
R241
10k
A3.3V
DGND
D5V
FL204
CL803
R225 33
MRAS
R228
33
MCAS
BA0
BA1
MCSO
MA10
R227
33
MA11
R224 33
MA0
MA1 R223 33
MA2 R222 33
R219 33
R221 33
MA3
MA5
MA4 R220 33
R218 33
MA7 R217 33
MA8
MA6
R215 33
R216 33
MA9
R/W
UDS
HAD0
HAD2
HAD1
HAD3
HAD4
HAD5
HAD6
HAD8
HAD9
HAD7
HAD10
HAD11
HAD12
HAD13
HAD14
HAD15
+1.8V
HA1
(Page 53)
R231 33
D3.3V
G4
G5
C265
0.01
C266
0.01
C267
0.01
R256
4.7k
R244
4.7k
C271
0.01
C268
0.01
C269
0.01
C270
0.01
JIG_MOD
G6
G7
48
48
HCD-C770/C990
(6/10)
G1
G2
CL801
128Mbit SD-RAM
C253
0.01
IC202
MT48LC4M32B2-7
C254
10
C257
10
C217
0.01
C258
0.01
G3
C219
0.01
MD0
MD15
MD1
MD14
MD2
MD13
FL202
C234
0.01
MD3
MD12
MD4
MD11
MD5
MD10
MD6
MD9
MD7
MD8
C226
0.01
FL203
C238
0.01
16Mbit PROGRAMMABLE
IC204
MR27V1602ETP
C239
0.01
UDS
HA21
WE
N.C.
A18
A19
A17
A8
A7
A9
A6
A10
A5
A11
A4
A12
A3
A13
A2
A14
A1
A15
HA19
MDQM0
HA20
MDQM1
HA18
HA9
MWE
HA8
HA10
MCAS
HA7
MRAS
MCLK
MCSO
R251
10k
HA11
HA6
HA12
HA5
HA13
MA11
MA9
BA0
MA8
BA1
MA7
MA10
MA6
MA0
MA5
A0
A16
MA1
MA4
CE
BYTE
HA4
HA14
HA3
HA15
HA2
HA16
HA1
MA2
HA17
MA3
VSS
VSS
R/W
C242
0.01
MDQM2
HAD15
DQ15
OE
MDQM3
HAD0
HAD7
DQ0
DQ7
DQ8
DQ14
HAD8
HAD14
HAD1
MD16
MD31
C244
0.01
HAD6
DQ1
DQ6
DQ9
DQ13
HAD9
HAD13
HAD2
(Page 48)
MD17
MD30
MD18
MD29
MD19
MD28
MD20
MD27
MD21
MD26
MD22
MD25
MD23
MD24
HAD5
DQ5
DQ2
HAD10
C245
0.01
HAD12
DQ12
DQ10
HAD3
HAD4
DQ3
DQ4
DQ11
VCC
HAD11
C248
0.01
G5
ALE
HA3
HA2
HA1
HAD14
HAD15
HAD13
HAD12
HAD11
HAD9
HAD10
HAD7
HAD8
HAD6
HAD4
C315
0.01
HAD5
HAD2
G4
HAD1
ALE
C314
0.01
HAD0
C274
0.01
HAD3
C249
0.01
C204
0.01
C319
33p
BUS INTERFACE
C356
0.01
49
HA21
HA20
HA19
HA18
HA17
HA15
HA16
HA14
HA13
HA12
HA11
C355
0.01
G7
49
HA10
HA8
HA9
HA7
HA6
HA5
G6
HA4
IC215
SN74ALVCH16841
DGGR
HCD-C770/C990
7-19. SCHEMATIC DIAGRAM – DVD Board (7/10) – • See page 71 for Waveforms.
(7/10)
R600
100
Z2
Z3
(Page 52)
PLOCK
Z4
Z1
XST
C608 0.1
DIN
DIN
C604
56p
DOUT
R687
1k
SPDIF
V16
V14
V15
V13
V12
V9
DGND
C635 0.01
V11
V8
V6
V7
V5
C627
0.01
V3
C616
0.1
V4
R614
33k
V1
C626
0.01
V10
R606 100
C611 0.01
V2
R608
3.3k
DOUT
R607 100
R603 100
R602 1M
R605 100
X600
12.288MHz
R604 100
C603
22p
R611
100
CKOUT(O)
VF(O)
R(I)
DVDD
DVDD
DIGITAL AUDIO
R623 100
A11
NC
A12
NC
A13
A10
A9
A8
A14
WE
A15
NC
D9
D8
D6
D7
D11
D10
VDD
VSS
D5
VSS
VDD
D4
D12
D3
D13
D2
BLE
D14
D15
D1
BHE
A0
D0
V17
V20
V18
V19
V21
V22
V23
V24
V25
V26
V27
V28
DA03V
PM
XMODE(I)
CKSEL1(I)
CKSEL0(I)
DOSEL1(I)
DOSEL0(I)
DVDD
MODE1(I)
DGND
CL(I)
CE(I)
MODE0(I)
XSEL(I)
DGND
C652
220
4V
DISEL(I)
V29
SPDIF(O)
V30
DO(O)
DIGDI
V31
R629 100 DOUT
V32
V34
SPDIF
DIN0(I)
DI(I)
CS
DIN
DIN1(I)
ERROR(O)
R628 100
R631
100
A7
DIN2(I)
IC606
LC89056W
BPSYNC(O)
OE
C637
0.01
DGND
INTERFACE
R625
3.3k
DO
IC604
IS61LV6416-15EL10(ISSI)
R616
5.6k
V33
DGND
LOCK(O)
ERR
A5
VIN(I)
F2(O)
C636
0.1
S-RAM
R615
4.7k
A1
LPF(O)
A2
AVDD
F1(O)
A3
F0(O)
A6
(Page 48)
AGND
A4
BCK(O)
LRCK(O)
DATA(O)
DVDD
DGND
XSTATE(O)
XMCK(O)
XOUT(O)
EMPHA(O)
CSFLAG(O)
XIN(I)
SPDIF
AUDIO-(O)
C617
0.1
C613
10
FL605
C634
0.1
C640
0.01
C642
0.01
V3
V13
V1
V2
V34
V33
V23
V22
V24
V26
V25
V28
V27
V29
V32
V31
V30
R634
1k
RSTDIR
L602
10µH
C641
0.01
R642
100
R640 100
CSDIR
DIGCLK
R639
100
SLR
C609
0.1
0.01
(Page 53)
C639
0.1
C612
10
C646
C638
0.1
C648
0.1
G
O
C647
0.01
C661
0.01
EXD1
B1
C653
0.01
BCK
SLR
LRCK
+2.6V REGULATOR
R637
100
V15
R677 220
R676 220
R674 220
R675 220
CW
LR
R672
100
R673 220
256FS
Z3
R661
100
C644
0.01
RSTDSP
C668
0.01
Z2
Z4
C671
0.01
Z1
FL606
0
I
IC605
NJM2391DL1
-26(TE1)
V16
C650
0.01
V17
V14
X601
13.5MHz
R645
10k
V12
V11
SCK
R648
100
V10
R689
10k
V9
LRCK
FL604
CDDOUT
FL603
V8
DIGITAL AUDIO
DSMCK
BCK
R956
10k
DSBC
R700
10k
V7
SIGNAL PROCESSOR
IC607
CXD9617R
LR
SDATAL
LRCKO
R655 100
SDATAR
BCKO
R658 100
V6
V5
C674
10
SDATAC
SDATALF
256FS
R659 33
SDATALS
D1
R662 100
SDATARS
D2
R664 100
D3
R666 100
D4
R667 100
C667
10
DIGITAL AUDIO
C673
0.01
C643
220
4V
R663
100
R682 10k
V20
IC612
CXD9633Q
R684 10k
V18
V19
PROCESSOR
LRCKI
BCKI
(Page 52)
C651
0.01
R686 10k
CW
R688 10k
2FS/EX
R692 100
SYNC
R695 100
R671
100
INIT
R998
10k
C679
0.01
C660
0.01
GP9
C669
0.01
C672
0.01
ERR
C670
0.01
BST
HCS
DSPDO
HACN
R919
10k
DIGDI
R962
10k
R960
10k
R961
10k
R972
10k
C676
0.01
DIGCLK
R680
100
R679 100
V4
C675
0.01
V21
R699
100
C677
0.01
B2
B3
A2
B4
A1
(Page 46)
(Page 51)
50
50
HCD-C770/C990
• See page 71 for Waveform.
(Page 53)
A1
A2
D5V
(Page 50)
(8/10)
C1
CN900
8P
Y4
AMPCLK
AMPDATA
CQRST
I2CDATA
I2CCLK
DIGDI
DDSPDO
DIGCLK
P-PWM
PM
RSTDSP
HCS
BST
DHACN
DGP9
DERR
DPLOCK
D903
1SS355
CSDIR
MUTEG
R955
10k
DXST
CS1
MUTEN
CS2
AMPRST
R957
10k
INVERTER
RSTDIR
Q903
2SC2712-GL
-TE85L
DO
JW903
0
R907
3.3k
R918
820
R917 820
Y1
IN
RESET
R910 100
JW900 100
TP901
R916 100
TP902
R914 100
R915 100
C901 0.01
(NC)
R912 100
R959 1k
R908
10k
Y4
2PIN
R909 10k
Y3
CLK
R911 100
OUT
R913 100
Y2
R906
3.3k
VPP
I/P-SEL
Y2
Y3
GND
Y1
VDD
CS3
(Page 52)
I2H
LT
RSTAD
(Page 52)
SYNC
2FS/EX
AV1
AV0
R922 10k
X901
20MHz
RDSC
DGND
C2
6.5V
C3
SIRCS
R971 10k
(Page 53)
PSW
C4
CN005
19P
SYSTEM CONTROLLER
R929 15k
TP050
6.5V
DRST
DGND
TP051
R069 0
EB
ENB
TP052
R068 0
EA
TP053
R065 0
K1
TP054
R063 0
K0
TP055
R058 0
K2
TP056
R055 0
FDATA
TP057
R053 0
FCS
TP058
R070 0
SIRCS
TP059
R052 0
FCLK
R047 0
DIMM
R948
10k
C5
IC901
mPD703033BYGF
-M01-3BA
FB005
R932 10k
DVDPW
RDSD
OCP
STPOW
EB
R937 10k
C921 100p
EA
R939 10k
C908 100p
K2
∗
R685 1k
∗ R935
4.7k (C990)
R933
10k
R935
10k (C770:US,CND)
C6
ENA
R899 2.2k
KEY1
KEY0
KEY2
AV2
R993
1k
R941 3.3k
C905 330p
K1
R942 3.3k
C906 330p
K0
R943 3.3k
C907 0.001
FDATA
FCS
FM
R946
10k
C7
R944 10k
SIRCS
FCLK
(Page 63)
R969
330
DIMM
DGND
FB006
TP061
R057 0
TP062
R056 0
TP074
R061 0
LCS
TP075
R062 0
LCLR
Q900
DTA114EKA
-T146
R991
10k
(C990)
MUTING
R963
∗
(US,CND,AUS)
IODATAI
IOCLK
∗ R963
IOLAT1
RELAY
INIT
HPSW
LCLR
LCS
FCS
FDATA
FCLK
DIMM
TUCLK
TUDO
TCE
CONTROL
ST-LED
TUDI
STANBY-SW
TUN
MUTING
FMUTE
Q902
DTA114EKA
-T146
IORST
LCLR
PARA-DO2
LCS
R936 1k
R967 100
POWER-SW
R926 100
CONTROL
STBY-LED
R968 100
TP060
5V
AUMUTE
DGND
4.7k
(US,CND)
2.2k
(AUS)
∗ R981
1.5k
(AUS)
4.7k
(EXCEPT AUS)
5V
(Page 52)
R965
10k
C913
0.01
C914
0.01
R951
10k
R981
∗
R970
10k
D-SEN
R979
47k
DISC
SIRCS
LOADING
DETECT
R984
47k
DISC INSERT
C917
0.1
C918
100p
R977
22k
DETECT
R983
47k
D906
1SS355
KEY INPUT
DETECT
IC903
PST9126NL
IN
GND OUT
DETECT
GND
SIRCS
Q914
2SC2712-GL
-TE85L
WAKE UP
R978
1k
Q906
2SC2712-GL
-TE85L
NC
Q913
2SA1037AK
R985
470k
IC904
PST9140NL
(Page 52)
IN
Q907
2SC2712-GL
-TE85L
GND OUT
C923
0.1
D904
1SS355
GND
R980
47k
NC
R989
0
DETECT
K0
C922
0.1
K2
SEN1C
R987
47k
R986
47k
R988 0
U5V
KEY INPUT DETECT
51
51
HCD-C770/C990
(Page 53)
DA05V
(Page 53)
B1
B2
B3
B4
(Page 50)
12V
7-21. SCHEMATIC DIAGRAM – DVD Board (9/10) – • See page 71 for Waveforms.
CN001
12P
DGND
(9/10)
SCK
R026 0
TP030
SCK
DGND
LRCKO
R028 0
TP031
BCKO
R029 0
TP032
D3
R031 0
TP033
D2
R032 0
TP034
D1
R034 0
TP035
C1
LRCKO
(Page 56)
BCKO
R657
1k
D3
R626
1k
R610
2.2k
R609
470
D2
+5V REGULATOR
L600 10µH
O
R669
1k
+10V REGULATOR
IC600
NJM78M05DL1A
-TE1
I
O
G
I
G
R636
4.7k
C658
470p
R647
220
R649
4.7k
R696
220
R635
10k
C645
220p
DGND
FB003
TP036
6.5V
6.5V
C618
10
16V
C620
0.1
A/D CONVERTER
C615
0.1
VCC
R646
4.7k
C678 220p
R652 4.7k
R618
4.7k
IC610
NJM2904V(TE2)
R619
47k
DGND
DIN
C552 0.1
D4
C623
10p
R651 10k
C655
C657 100
0.1 6.3V
BCKO
C656 0.1
C654 100 16V
SCK
(Page 50)
(AEP)
CN002 29P
R630 470
R627 2.2k
RDSD
R024 0
TP001
RDSC
R022 0
TP002
RDATA
RCLK
LRCKO
R621 100
LT
BCKI
R622 100
DIGCLK
LRCKI
R624 100
C632
0.01
TUDO
R668
1k
RSTAD
EXD1
IC602
(Page 51)
IC603
NJM2904V(TE2)
LOW-PASS
GND
IC608
AK4382AVT-E2
R620
100
C630 C631
10
0.1
VCC
FILTER
C622
10
16V
C625
10
16V
I/P-SEL
FILTER
D/A CONVERTER
C629
470p
6.5V
LOW-PASS
R644
10k
C619
0.1
C621
470p
(Page 53)
0.1
GND
C633
C601
0.1
C628 10 16V
C600
0.1
C624 0.1
C602
100
16V
R612 47k
C605
0.1
R613 4.7k
C607
0.1
C614 10 16V
C606
100
6.3V
C610
47
6.3V
(Page 51)
D1
DGND
IC601
µPC2910T-E1
R660
220
R650
4.7k
TP003
TUNDO
C662
220p
TUDI
R002 0
TP004
TUN
R003 0
TP005
TCE
R004 0
TP006
TUCLK
R005 0
TP007
TUNDIN
TUNSTE
C663
470p
R654 220
C659
220p
DIGDI
TUNCE
TUNCLK
R665
10k
R653
4.7k
PCM1800
R006 0
TP008
R007 0
TP009
D.GND
D.IN
R617
0
R656
0
D.DND
FB902
C2
TP010
FB901
D.OUT
C925
0.1
C3
R931
1k
D.GND
R054 0
TP011
I/P-SEL
P-PWM
TP012
C4
NC
AV0
R014 0
TP013
AV1
R016 0
TP014
AV2
R018 0
TP015
AUMUTE
R020 0
TP016
FM
R001 0
TP017
AV0
C5
C900
0.1
C6
AV1
C902
0.1
AV2
(ROTARY ENCODER)
IC902
PT8300
IC906
PT8300
R974
R921
0
100 IODATAI
IORST
U5V
IOCLK
CHANGER CONTROLLER
(MOTOR SWITCH)
D-SEN
R920 100
R928
0
IOLAT1
R071
0
R076
0
MA1
MEN10
SEN2
MA2
MEN11
DGND
ENABLE SWITCH
IORST
SEN1
(Page 59)
TU-ON
Q908-910
SEN1C
(Page 51)
AUMUTE
ERR
C924
0.1
CHANGER CONTROLLER
R025 0
TP018
R027 0
TP019
R030 0
TP020
R033 0
TP021
FB001
TP022
L
PARA-DO2
C7
A.GND
Q908
DTC124EKA
-T146
R
A.GND
R992
10k
R924
100
R.IN
A.GND
Q909
DTC124EKA
-T146
L.IN
2FS/EX
Q910
DTC124EKA
-T146
SEN3
MB1
MEN12
SEN4
MB2
MEN13
SEN5
MC1
MEN20
SEN6
MC2
MEN21
AMPRST
R035 0
TP037
MEN22
MUTEG
R037 0
TP038
MEN23
MUTEN
R038 0
TP039
AMPDATA
R040 0
TP040
AMPCLK
R042 0
TP041
DGP9
CS1
R044 0
TP042
HACN
CS2
R045 0
TP043
CS3
R046 0
TP044
DRST
R048 0
TP045
OCP
R049 0
TP046
HPSW
R050 0
TP047
10V
10V
CN004 17P
MGND
INIT
SEN7
M12V
PGMUTE
SEN8
(Page 53)
R930
10k
CN006
28P
RB901
10k
TP078
D+5V
NSMUTE
LEVEL SHIFT
R954
10k
RB902
10k
IC900
TC74HCT7007AF
DGND
SCDT
XST
TP079
M+12V
SHIFT
R925 100
DXST
R927 100
ERR
R953 100
DERR
GP9
R900 100
M+12V
DGND
TP080
R901 100
MGND
LAT1
MGND
LAT2
TP081
PLOCK
R902 100
R903 100 DHACN
DPLOCK
R904 100
DSPDO
D.SENSOR
LAT3
TP082
R012 0
SEN7
TP083
R074 0
SEN1
TP084
R073 0
SEN2
SW3
DGND
DDSPDO
SW1-A
EN
D901 1SR154
R905
100
SW1-B
TP085
SEN3
TP086
SEN4
TP087
SEN5
TP088
SEN6
TP089
MA1
TP090
MA2
DIAG
SW2-A
R945
10k
SW5-A
R990
15k
R949
10k
R940
100
LOD-POS
C909
0.22
LOD-NEG
TP091
MB1
TP092
MB2
TP093
MC1
TP094
MC2
TP095
SEN8
TP096
MEN10
TP097
MEN11
TP098
MEN12
TP099
MEN13
TP100
MEN20
TP101
MEN21
TP102
MEN22
TP103
MEN23
RELAY
FMUTE
R075 0
TP049
HPMUTE
AND GATE
SLD-POS
R999
1.5k
R950
47k
SLD-NEG
DGND
PSW
SW4
STPOW
D900
1SR154
SW2-B
IC905
TC7S08F
RESET
RELAY
Q911,912
GND
RELAY
LED DRIVE
STPOW
STPOW
ELV-POS
SW5-B
Q901
2SD1819A-QRS
-TX
SLD-E1
SLD-E2
R964
47k
RESET SWITCH
D902
1SS355
SLD-E3
GENERATOR
IC907
PST9140NL
NC
SLD-E0
GND
RESET SIGNAL
D907
1SS355
GND RESET
IN
ELV-NEG
DVDPW
R938
10k
Q912
2SC2712-GL
-TE85L
VCC
DVDPW
POWER-AD
(Page 53)
AGND
C926
0.1
C903
100
6.3V
C927
0.1
C912
47
6.3V
C910
0.22F
5.5V
Q911
DTC124EK
C911
47
6.3V
I2CDATA
R934
10k
I2C_SIO
R966
220
CQRST
ZIVARESET
I2CCLK
ELV-E0
I2C_SCL
I2H
ELV-E1
ELV-E3
E5.6V
ST-LED
STANBY-SW
I2C_CTRL
ELV-E2
5V
(Page 41)
(Page 56)
HPSW
(Page 53)
(Page 51)
52
52
(Page 48)
HCD-C770/C990
(10/10)
6.5V
(Page 51)
DGND
+5V REGULATOR
IC004
µPC2905T-E1
O
DA05V
I
G
(Page 52)
DA05V
(Page 48)
DGND
+3.3V REGULATOR
+1.8V REGULATOR
IC005
µPC2933T-E2
IC006
µPC2918T-E1
O
DA03V
(Page 50)
I
O
G
I
G
DGND
C017
0.1
C016
0.1
C015
0.1
C014
0.1
C018
0.1
C020
220
4V
C019
0.1
D5V
(Page 51)
+5V REGULATOR
IC003
µPC2905T-E1
+1.8V
O
D5V
(Page 48)
I
G
D3.3V
C012
0.1
C013
0.1
DGND
A3.3V
FB008
FL003
FB007
6.5V
(Page 52)
FB010
FL004
FB009
E5.6V
(Page 52)
12V
C005
220
4V
(Page 52)
C006
47
16V
M12V
Q002
2SB906(TE16L)
D3.3V
A5V
Q004
2SB906(TE16L)
+3.3V REGULATOR
+5V REGULATOR
IC001
µPC2933T-E2
IC002
µPC2905T-E1
O
A3.3V
I
O
R067
470
Q003,004
R066
1k
R079
1k
R011
1k
R009
1k
Q001,002
B+ SWITCH
FB012
FL005
FB011
I
TP064
G
G
TP065
(Page 44)
FB014
C008
0.1
C001
100
6.3V
C010
0.1
C011
0.1
Q003
DTC124EKA
-T146
Q001
DTC124EKA
-T146
C003
100
6.3V
FL006
CN008
13P
TP063
B+ SWITCH
FB013
TP066
C004
47
16V
R017 0
TP067
R019 2.2k
TP068
R021 0
TP069
R023 0
TP070
TP071
MGND
TP072
12V
6.5V
DVD3.3V
E5.6V
RESET
P.CONT1
P.CONT2
A/D
MGND
DGND
DGND
R060
0
MGND
R059 0
M12V
R051 0
C007
10p
TP073
TP048
DGND
AGND
53
53
AGND
RELAY
POWER-AD
RESET
STPOW
DVDPW
P.CONT3
(Page 52)
(Page 52)
(Page 70)
HCD-C770/C990
7-23. PRINTED WIRING BOARD – AMP Section (1/2) –
1
• Semiconductor
Location
Ref. No.
Location
D101
D102
D103
D104
D105
D106
D180
D181
D190
D191
D192
D331
D332
D333
D334
D335
D336
D341
D342
D343
D344
D345
D346
D361
D362
D363
D364
D365
D366
K-6
K-6
K-6
J-6
J-6
J-6
D-2
D-2
H-9
H-9
E-2
E-10
E-8
E-7
E-6
E-4
E-3
H-9
H-8
H-6
H-5
H-4
H-3
G-9
G-7
G-6
G-5
G-3
G-2
IC300
IC303
IC305
IC308
IC310
C-9
B-9
D-8
D-5
D-3
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q108
Q109
Q110
Q111
Q112
Q113
Q114
Q191
Q192
K-8
K-8
K-8
K-7
K-7
K-7
J-8
J-7
K-7
K-7
J-7
J-7
K-8
K-6
B-6
E-2
2
3
4
5
6
7
8
9
10
A
AMP BOARD (COMPONENT SIDE)
2
IC303
B
1
3
C
IC3003
IC310
IC308
IC305
1
4 5
D
E
F
G
H
I
J
K
11
L
1-685-079-
(CHASSIS)
54
54
(11)
HCD-C770/C990
7-24. PRINTED WIRING BOARDS – AMP Section (2/2) –
1
2
3
4
5
6
8
9
10
11
(Page 42)
M301
(FAN)
M
A
7
C
AMP BOARD (CONDUCTOR SIDE)
12
13
14
15
16
(Page 42)
D
DVD BOARD
CN001
• Semiconductor
Location
DVD BOARD
CN004
2
B
E
IC302
1
3
C
R
PIN301
Q492
AUDIO BOARD
CN204
(Page 58)
D
C111
C112 C122
C121
C113 C123
C114 C124
C115 C125
C116 C126
E
2
1
2
1
2
1
2
1
2
1
2
1
IC301
F
C131
IC304
C132
IC306
C133
IC307
C134
IC309
C135
IC311
C136
HP BOARD (COMPONENT SIDE)
G
20
19
20
19
20
19
20 19
20
19
20
19
H
I
11
1-685-887-
(11)
J401
SPEAKER
(Page 69)
(FRONT VIEW)
J
FRONT
R
9
–
10
+
11 12
– +
CENTER
5
–
6
+
7
–
8
+
WOOFER
REAR
R
1
–
2
+
3
–
4
+
REAR
L
HP BOARD
POWER BOARD
CN904
FRONT
L
(CONDUCTOR SIDE)
J
1
5
J900
K
PHONES
E
IC401
E
L
11
11
1-685-079-
55
55
(11)
1-685-887-
(11)
Ref. No.
Location
D311
D312
D313
D314
D315
D316
D321
D322
D323
D324
D325
D326
D351
D352
D353
D354
D355
D356
G-3
H-5
H-6
H-8
H-9
I-10
H-4
H-6
H-7
H-8
H-10
H-11
E-4
E-5
E-7
E-8
E-9
E-10
IC301
IC302
IC304
IC306
IC307
IC309
IC311
IC401
F-4
B-6
G-5
G-7
G-8
G-9
G-11
K-10
Q190
Q900
Q901
B-7
K-15
L-16
HCD-C770/C990
7-25. SCHEMATIC DIAGRAM – AMP Section (1/2) –
(1/2)
CN300
5P
A19
32V
A1
C300
2200
35V
32V
A2
PGND
A3
IC303
BA033FP-E2
O
I
LAT3
SCDT
SHIFT
A4
C306
0.01
C311
0.01
C312
100
10V
G
C309
0.1
C310
0.01
C320
100
10V
FB301
A5
FB304
C323
0.01
C325
100
10V
C324
0.01
R308
1.0k
C326
47
6.3V
R313 1.0k
G
12V
R301
1.0k
Q190,191
FAN MOTOR CONTROL
O
R312 1.0k
I
NSMUTE
IC302
BA05FP-E2
R309 1.0k
(FAN)
R395
180
R399
4.7k
Q191
DTC124EKA
R311 1.0k
R397
180
PGND
+3.3V REGULATOR
R310 1.0k
R396 180
CN302
2P
M301
+5V REGULATOR
Q190
2SB1013
INIT
R398
47k
12V
PGMUTE
PGND
(Page 70)
C327
0.01
FB308
A6
R304
100
FB307
LAT2
SHIFT
SCDT
NSMUTE
INIT
PGMUTE
D3
C348
0.01
BCKO
C328
0.1
LRCKO
C349
0.01
C331
0.1
R305
100
C329
220
10V
A7
C330
0.01
C336
100
10V
C350
100
10V
C352
0.01
STREAM PROCESSOR
IC305
CXD9634Q
R321
100
D2
A8
R307
100
BCKO
C355
0.1
LRCKO
C344
0.01
C337
0.1
CN301
12P
C368
0.1
C351
0.1
6.5V
R330
100
6.5V
C358
0.01
DGND
R320
100
SCK
A9
DGND
R315 100
D1
R316 100
D2
D1
STREAM PROCESSOR
D2
R317 100
D3
IC308
CXD9634Q
D3
R318 100
BCKO
R319 100
LRCKO
BCKO
R333
100
LRCKO
(Page 52)
R325
22
DGND
R322 47
SCK
C359
0.01
C372
0.1
SCK
DGND
C378
0.1
C373
0.01
A10
A11
R335
100
SCK
A12
A13
(Page 59)
AUDIO BOARD
CN204
LAT1
SCDT
SHIFT
C388
0.01
C387
0.01
C389
100
10V
C391
0.01
PIN301
1P
R
NSMUTE
INIT
FB315
C390
0.01
PGMUTE
FB314
R337
1.0k
C393
0.01
R343
100
R191
15k
D180
RB411D
A14
CN305
17P
C394
0.1
D1
R334 470
INIT
R336 470
PGMUTE
R338 0
NSMUTE
BCKO
INIT
Q192
DTC124EKA
PGMUTE
NSMUTE
D192
UDZSTE-1713B
POWER ON
D181
MA111-TX
C392
100
10V
LRCKO
MUTING
DGND
R339 100
SCDT
R340 100
SHIFT
R341 100
LAT1
C474
470
16V
SCDT
SHIFT
R470
22k
DGND
C409
0.01
R348
100
A15
LAT1
R342 100
LAT2
R344 100
LAT3
LAT2
R471
22k
LAT3
C471
120p
R473
22k
DGND
(Page 52)
R346 0
EN
R347 0
DIAG
C472
100p
R472
22k
EN
C399
0.1
STREAM PROCESSOR
IC310
CXD9634Q
R474
33k
A16
DIAG
R349
100
HPSW
DGND
R491
10k
C490
100
16V
C491
0.1
R490
10k
R485
24k
C483
100p
R475
24k
C473
100p
RELAY
HPMUTE
C493
47
35V
VCC
HEADPHONE AMP
IC401
NJM4580E(TE2)
C408
0.1
GND
SCK
A17
R902
68
L901
33µH
C904
0.1
R903
4.7k
C991
0.01
R350
100
L903
C410
0.1
Q900
DTC343TK
FB803
MUTING
FB805
J900
PHONES
C902
0.01
R900
4.7k
Q901
DTC343TK
FB804
MUTING
C903
0.01
L900
33µH
C992 R901
0.01
68
CN900
5P
R481
22k
CN309
5P
HP.L-CH
HP-SW
GND
HP-MUTE
HP.R-CH
HP.R-CH
HP-MUTE
GND
HP-SW
HP.L-CH
C481
120p
R483
22k
C482
100p
R480
22k
R482
22k
C484
470
16V
C415
0.01
C416
0.01
A18
C192
0
L902
R484
33k
(CHASSIS)
56
56
(Page 57)
HCD-C770/C990
7-26. SCHEMATIC DIAGRAM – AMP Section (2/2) –
(2/2)
POWER AMP
A1
A2
R300 10k
C181
0.01
IC301
CXD9702L
A4
A5
FB300
L300
0
D351
SFPL
C301
22
6.3V
C302
0.01
C162
0.1
L401
10µH
DIAG
EN
A3
C303
0.022
D361
SFPL
J401
C142
0.01
SPEAKER
C182
0.01
D311
LI116
D331
P6SMB39AT3
C452
1
D321
LI116
D341
P6SMB39AT3
C451
1
FRONT L
BUFFER
VCC
C304
0.022
FB303
C161
0.1
GND
IC300
MC74VHC1G04
X300
49.152MHz
C318
100
10V
R370
680
C319
0.1
C317
100
50V
C316
0.01
C313
0.1
C401
100
10V
C400
0.1
C111
0.01
C121
0.1
C141
0.01
FRONT R
C131
0.1
C308
0.001
WOOFER
C307
5p
R302
1M
L302
1µH
C432
10.0p
POWER AMP
A6
IC304
CXD9702L
A7
CENTER
C164
0.1
L402
10µH
D352
SFPL
C334
0.022
D362
SFPL
D312
LI116
D332
P6SMB39AT3
C453
1
D322
LI116
D342
P6SMB39AT3
C454
1
C144
0.01
REAR L
A8
C333
0.022
A9
FB309
C163
0.1
C143
0.01
REAR R
D190
C190
RB411D 2.2
C345
100
10V
C343
0.1
C342
100
50V
C341
0.01
C332
0.1
C407
100
10V
C406
0.1
C112
0.01
C122
0.1
C132
0.1
R103
100k
C102
1
R110
100k
R104
100k
C105
1
R109
100k
A19
Q103,104
R190
100k
C191
1
50V
POWER AMP
D191
RB411D
OVER LOAD
DETECT
IC306
CXD9702L
C168
0.1
L403
10µH
Q103
2SC2412
C148
0.01
Q104
2SC2412
Q110
2SC2412
Q109
2SC2412
R111
100k
Q109,110
OVER LOAD
D353
SFPL
C356
0.022
D363
SFPL
D313
LI116
D333
P6SMB39AT3
C455
1
D323
LI116
D343
P6SMB39AT3
C456
1
D102
MA111-TX
Q112
2SC2412
D105
MA111-TX
C106
1
D106
MA111-TX
Q111,112
OVER LOAD
A10
C354
0.022
A11
FB312
C362
100
10V
C365
0.1
C364
100
50V
C363
0.01
C353
0.1
C417
100
10V
C113
0.01
C414
0.1
C123
0.1
C167
0.1
C147
0.01
C166
0.1
C146
0.01
R112
100k
Q111
2SC2412
DETECT
C133
0.1
POWER AMP
(Page
56)
IC307
CXD9702L
L404
10µH
D354
SFPL
C376
0.022
D364
SFPL
D314
LI116
D334
P6SMB39AT3
C457
1
D324
LI116
D344
P6SMB39AT3
C458
1
R106
100k
D103
MA111-TX
Q106
2SC2412
C103
1
Q105,106
OVER LOAD
A12
C375
0.022
A13
FB313
C381
100
10V
C384
0.1
C383
100
50V
C382
0.01
C374
0.1
C423
100
10V
C418
0.1
C114
0.01
C124
0.1
C165
0.1
C145
0.01
C170
0.1
C150
0.01
R105
100k
Q105
2SC2412
DETECT
C134
0.1
POWER AMP
IC309
CXD9702L
L405
10µH
D355
SFPL
C397
0.022
D365
SFPL
D315
LI116
D335
P6SMB39AT3
R107
100k
C460
1
D104
MA111-TX
Q107
2SC2412
C104
1
D325
LI116
D345
P6SMB39AT3
C459
1
Q107,108
OVER LOAD
A14
C396
0.022
A15
FB318
C405
100
10V
C404
0.1
C403
100
50V
C402
0.01
C395
0.1
C425
100
10V
C424
0.1
C115
0.01
C125
0.1
C169
0.1
C149
0.01
C172
0.1
C152
0.01
R108
100k
Q108
2SC2412
DETECT
C135
0.1
POWER AMP
IC311
CXD9702L
L406
10µH
D356
SFPL
C413
0.022
D366
SFPL
D316
LI116
D336
P6SMB39AT3
C461
1
D326
LI116
D346
P6SMB39AT3
C462
1
R101
100k
D101
MA111-TX
Q102
2SC2412
C101
1
Q114
DTA114EK
Q101,102
OVER LOAD
A16
C412
0.022
A17
FB320
C171
0.1
R102
100k
C151
0.01
Q101
2SC2412
DETECT
Q113
DTC124EKA
Q113,114
C422
100
10V
C421
0.1
C420
100
50V
C419
0.01
C411
0.1
C427
100
10V
C426
0.1
C116
0.01
C126
0.1
C136
0.1
R113
100k
A18
57
57
PROTECT
DETECT
DETECT
HCD-C770/C990
7-27. PRINTED WIRING BOARDS – AUDIO Section –
• Semiconductor
Location
2
3
4
5
6
7
Location
B-2
A-4
A-4
IC201
IC202
B-2
A-5
Q201
Q205
Q206
Q207
Q208
Q220
Q221
Q222
Q223
E-2
E-5
E-5
E-3
E-3
E-2
E-2
A-4
A-3
AUDIO BOARD (COMPONENT SIDE)
A
IC202
B
IC201
11
1-685-073-
(11)
J205
C
VIDEO 1
R
AUDIO OUT
J206
VIDEO OUT
L
R
AUDIO IN
L
VIDEO IN
VIDEO 2
R
AUDIO IN
L
VIDEO IN
Y
PB/CB
P/CR
COMPONENT
VIDEO OUT
AUDIO BOARD
(CONDUCTOR SIDE)
D
E
E
AM
COAXIAL
FM
75Ω
E
SEL BOARD
E
E
E
E
E
FM/AM TUNER
PACK
F
SUPPLIED WITH
THE ASSEMBLED
BLOCK
SCAN SELECT
11
(11)
INTERLACE
R
AMP BOARD
PIN301
(Page 55)
E
DVD BOARD
CN002
K
(Page 42)
58
VIDEO BOARD
CN207
(Page 60)
58
SELECTABLE
1-685-889-
D201
D202
D203
1-685-073-
Ref. No.
1
11
(11)
HCD-C770/C990
7-28. SCHEMATIC DIAGRAM – AUDIO Section – • See page 71 for Waveform.
CN201
11P
L-CH
TD
C214
0.01
R212 220
TUNED
R-CH
C213
0.01
(AEP)
COAXIAL
10V
FM/AM TUNER
PACK
SUPPLIED WITH
A.GND
C201
330p
R201
4.7k
FM-DET
THE ASSEMBLED
BLOCK
A.GND
CL
R208 220
DO
R209 220
FM
75Ω
AM
CK
Q201
2C2412
L205
10µH
R292
1k
C215
1
R207
270
R204
47k
R202
1k
R205
100k
C216
1
R290
470k
C203
0.1
R293
1k
CE
R291
470k
Q221
2SC2412
AMP
AMP
DI
CN205
2P
C210
22
35V
C205
0.01
R294
330
R295
330
SELECTABLE
INTERLACE
CN202
29P
C211
22
35V
RDATA
RCLK
DO
C206
TUNDO
51
DI
TUNDIN
C208 56
C207
4.7
50V
TD
TUNSTE
X201
4.332MHz
CE
TUNCE
CL
TUNCLK
D.GND
IC201
BU1924F-E2
D.IN
D.DND
D.OUT
C221
22
35V
C223
0.1
L206
10µH
D.GND
I/P-SEL
J205
6P
C225
0.1
R223
10k
R218
10k
R217
33k
R225
33k
R215
6.8k
R214
6.8k
NC
C220
22
35V
AUDIO OUT R
AV0
AV1
(Page 52)
AV2
R229
100k
C234
1000p
R219
100
R233
10k
VIDEO IN
R231
75
C239
22
35V
R243
6.8k
A.GND
AUDIO INPUT
R
VSS
VEE
INH
A.GND
Q206
DTC124EK
IC202
MC14052 BDR2
R.IN
C222
22
35V
INVERTER
R244
10k
A.GND
L.IN
Q205
DTC124EK
AUDIO IN R
10V
10V
INVERTER
COMPONENT
VIDEO OUT
C226
0.1
Y
VIDEO 2
L
B
A
X3
X
X0
VDD
R250
10k
R251
75
TU-ON
R221
100k
SELECTOR
C235
22
6.3V
Y0
R232
6.8k
X1
R222
33k
AUDIO IN L
VIDEO OUT
AUMUTE
R220
100k
DGND
R238
10k
Y1
VIDEO 1
C237
22
6.3V
X2
C238
220p
Y3
R241
47k
Y
R235
47k
R237
6.8k
Y2
C236
220p
AUDIO OUT L
R226
33k
R224
100
C224
22
35V
C609
6800p
AUDIO IN R
C233
1000p
C608
6800p
R230
100k
R249
6.8k
AUDIO IN L
C241
22
35V
R242
10k
R247
10k
R236
10k
R252
10k
C227
22
35V
C228 0.1
R227 1k
C230 10 50V
COMPONENT
R253
47k
VIDEO OUT
C242
220p
R228
1k
PB/CB
R246
47k
VIDEO IN
C232
10
50V
CN204
2P
Q207,208
C240
220p
MUTING
Q207
DTC343TK-T
-146
COMPONENT
R
R239
1k
VIDEO OUT
AMP BOARD
(1/2)
PIN301
PR/CR
Q208
DTC343TK-T
-146
J206
6P
R245
1k
(Page 56)
CN208
11P
Y
CB
V-OUT
CR
R254
75
V1-IN
C243 10 6.3V
AV2
V2-IN
C245
10
50V
AV1
AVO
GND
D-IN
59
59
S201
SCAN SELECT
R213
47k
C204
560p
CNP205
2P
D202
MA111-TX
D201
UDZ-TE17-4.3B
RDS DECODER
R203
68k
Q223
DTC124EKA
Q220
2SC2412
R210 220
DI
Q222
2SA1037AK
R216
4.7k
C209
47
16V
R211 220
CE
Q222,223
B+ SWITCH
D203
MA111-TX
R206
470k
BUFFER
DO
(Page 61)
HCD-C770/C990
7-29. PRINTED WIRING BOARD – VIDEO Section –
• Semiconductor
Location
2
3
4
5
Location
IC204
IC206
IC207
IC208
IC209
D-2
D-4
B-5
D-3
B-4
Q210
Q214
A-4
A-4
VIDEO BOARD (COMPONENT SIDE)
A
B
16
9
1
8
IC207
IC209
11
1-685-072-
K
VIDEO BOARD
C
(11)
(Page 42)
(Page 58)
AUDIO BOARD
CN208
F
DVD BOARD
CN003
(CONDUCTOR SIDE)
J202
MONITOR
OUT
S VIDEO
VIDEO
4
2
3
1
IC208
D
IC206
Ref. No.
1
3
1
4 6
IC204
OPTICAL
DIGITAL IN
VIDEO 2
IC204
11
1-685-072-
60
60
(11)
HCD-C770/C990
7-30. SCHEMATIC DIAGRAM – VIDEO Section –
75Ω DRIVER
IC206
MM1510
C218
47
16V
C202
220
6.3V
OPTICAL RECEIVER
C252
0.1
SAG
PS
OUT
GND
VCC
IN
C248
22
6.3V
CN207
11P
D-IN
IC204
TORX179L
L202
10µH
GND
AVO
OPTICAL
DIGITAL IN
AV1
L209
10µH
VIDEO 2
V2-IN
AV2
V1-IN
C278
10
6.3V
VIDEO AMP, 75Ω DRIVER
VIDEO
C281
0.1
Y
CN203
14P
C296 470 4V
S VIDEO
R259
75
GND
VIDEO
C277
22 6.3V
63
IN3
VDD
IN2
NC
SW2
GND
IN1
C294
0.1
C295 100 6.3V
GND
C293 100 4.0V
SW1 OUT
C276
10 6.3V
C292 220 6.3V
VCC
R270
75
VIDEO INPUT
GND
IC209
NJM2285V
CB
FB204
C267
100
6.3V
D5V
FB206
D5V
GND
C287
0.1
C298 100 4V
C299 22
I/P SW
CR
IC207
NJM2235V
SELECTOR
C279
0.01
FB205
SELECTOR
C297 220 6.3V
R268
75
62
6.3V
FB203
C272
0.1
VIDEOY
GND
FB202
C300 100 6.3V
R273
75
C301 22 6.3V
61
C290
0.1
C289
10
6.3V
VIDEOC
C265
10
6.3V
GND
FB201
C274
10 6.3V
VIDEOV
C302 100 6.3V
VS/WIDE
C275
0.1
C291
10
6.3V
Q210
DTA114EKA
C280
1.0
50V
Q210,214
C283 1.0
WIDE SWITCH
R278
10k
(Page 59)
V-OUT
CB
GND
R269
75
CR
R256
10k
C282
0.1
MONITOR
OUT
C284
100
6.3V
64
C288
0.1
J202
2P
C285
0.1
IC208
MM1568
65
R267
75
L207
10µH
R286
10k
Q214
DTC144EKA
R266
10k
50V
C286 0.1
61
61
R265
10k
(Page 48)
HCD-C770/C990
7-31. PRINTED WIRING BOARDS – DC-DC CONVERTER Section –
• Semiconductor
Location
Ref. No.
1
2
3
4
5
Location
D806
D807
D808
D809
D810
D812
E-2
E-2
E-2
E-2
E-3
C-5
IC801
D-3
Q803
Q804
E-2
D-2
DDCON BOARD (COMPONENT SIDE)
A
B
11
1-685-070-
(Page 64)
CONTROL BOARD
CNP804
N
C
POWER LED BOARD
(11)
DDCON BOARD (CONDUCTOR SIDE)
D812
STANDBY
M
IC801
G
10
KEY BOARD
CN811
(Page 64)
9
DVD BOARD
CN005
D
1
2
(Page 42)
18
P
POWER SW BOARD
CNP911
(Page 69)
1
1
2
DC- DC CONVERTER
E
L
E
E
FL BOARD
CN805
(Page 66)
1-685-07011
(11)
62
62
11
1-685-071-
(11)
HCD-C770/C990
7-32. SCHEMATIC DIAGRAM – DC-DC CONVERTER Section –
CN814
19P
CN804
5P
6.5V
DGND
ENB
ENA
KEY1
KEY0
(Page 65)
KEY2
FDATA
FCS
SIRCS
(Page 51)
FCLK
DGND
DIMM
DGND
CN812
12P
5V
VSS
P1(G)
P8(R)
P2(R)
P7(G)
P3(G)
P6(R)
P4(R)
P5(G)
VDD
P11
P9(G)
CLR
STB
IC801
NJU3713G
P10(R)
LED DRIVER
CLK
P12
0.001
C805
0.01
DATA
LCLR
C804 0.01
LCS
C803
R814 47k
POWER-SW
C802 0.001
STBY-LED
CN807
2P
(Page 65)
R813 100
R812 100
(Page 70)
R811 100
FB801
FB800
FB802
R810 100
C806
22
6.3V
CNP809
2P
CN803
10P
R838 47
CN802
2P
SIRCS
5V
R804
470
DGND
R841 100
FDATA
R842 100
FCLK
R843 100
FCS
D812
SLR325VR-T31
DIMM
STANDBY
FL1
D806
MA111-TX
C821
10
10V
FL
VFL
R850
3.9k
L801
47µH
D807
MA111-TX
T801
DC-DC
Q803,804
CONVERTER
D808
MA111-TX
OSC
C820
0.01
D809
MA111-TX
Q803
2SD1624-T
-TD
RECT
63
63
D810
UDZS-TE17
-6.2B
R874
33k
D806-809
Q804
2SD1624-T
-TD
C823
10
50V
C822
0.1
R855
100
(Page 67)
HCD-C770/C990
7-33. PRINTED WIRING BOARDS – CONTROL Section –
• Semiconductor
Location
Ref. No.
D801
D802
D803
D804
D805
1
Location
A-6
A-5
A-4
A-3
A-2
2
3
4
5
6
7
KEY BOARD (COMPONENT SIDE)
A
11
S820
S818
D805, S819
DISC5
(DISC5)
S816
D804, S817
DISC4
(DISC4)
D803, S815
DISC3
(DISC3)
S814
D802, S813
DISC2
(DISC2)
S812
1-685-069-
(11)
1-685-069-
(11)
D801, S811
DISC1
(DISC1)
KEY BOARD (CONDUCTOR SIDE)
B
11
M
DDCON BOARD
CN812
(Page 62)
CONTROL BOARD (COMPONENT SIDE)
C
D
11
1-685-068-
VOL BOARD
E
(11)
ROTARY ENCODER
VOLUME
CONTROL BOARD (CONDUCTOR SIDE)
3
1
N
DDCON BOARD
CN804
11
1-685-887-
+
(11)
NEXT
F
PRESET
−
(Page 62)
PREV
DISPLAY
SOUND, −
G
BAND
FUNCTION
1-685-068-
11
(11)
S821
FIELD, +
64
64
HCD-C770/C990
7-34. SCHEMATIC DIAGRAM – CONTROL Section –
R873
220
DISC1
DISC2
DISC3
(DISC1)
(DISC2)
(DISC3)
(DISC4)
(DISC5)
DISC4
R835
220
S813
R834
330
R833
470
D805
SML-020MDT
S815
S812
R832
680
R829
1k
D804
SML-020MDT
DISC5
S814
S816
R830
1.5k
R831
2.2k
D803
SML-020MDT
DISC4
S818
S820
R828
4.7k
R827
10k
D802
SML-020MDT
DISC3
S817
S819
R849
680
R860
1k
S821
S822
FIELD,+
SOUND,-
S823
S824
S825
GND
DISPLAY
BAND
R801
470
R802
680
FUNCTION
R826
33k
R809
220
D801
SML-020MDT
DISC2
R844
470
DISC5
CNP808
5P
S811
R837
330
R800
330
R803
1k
(Page 63)
DISC1
S804
S802
S801
S805
S803
CN811
12P
NEXT
R825
820
R824
820
R823
820
R822
820
R821
820
R820
820
R819
820
R818
820
R817
820
R816
820
PREV
+
(Page 63)
CNP813
3P
CN820
3P
PRESET
-
C800
0.01
ENB
S800
ROTARY
GND
ENCODER
VOLUME
ENA
C801
0.01
65
65
HCD-C770/C990
7-35. PRINTED WIRING BOARD – FL Board –
FL BOARD (COMPONENT SIDE)
11
1-685-886-
(11)
FL BOARD (CONDUCTOR SIDE)
1
3
FLUORESCENT INDICATOR
TUBE
11
L
DDCON BOARD
CN803
(Page 62)
66
66
(11)
IC101
IC802
1-685-886-
HCD-C770/C990
7-36. SCHEMATIC DIAGRAM – FL Board –
FL801
REMOTE
CONTROL
RECEIVER
IC101
NJL62H400A-1
FL DRIVER
IC802
MSM9202-05GS
-KDR1
C808
0.01
C809
22
6.3V
CN805
10P
SIRCS
R815
47
C813
0.1
5V
47p
C818
C817 0.001
VFL
0.001
FL
C816
FL1
C815 100p
C814 0.001
DIMM
(Page 63)
C819
0.1
R839
10k
67
67
P29
P30
P31
P32
P33
P34
P35
12G
11G
8G
9G
7G
6G
5G
4G
OSC
FCS
10G
C818,R840
3G
FCLK
1G
FDATA
2G
C812
47
6.3V
R840 3.3k
DGND
1G
3G
2G
4G
5G
7G
6G
9G
8G
10G
12G
P34
11G
P33
P25
P37
P32
P24
P28
P31
P23
P35
P30
P22
P36
P29
P21
P27
P28
P19
P20
P26
P26
P27
P17
P18
P24
P25
P23
P16
P22
P14
P15
P21
P13
P17
P8
P20
P16
P7
P12
P15
P6
P11
P14
P5
P18
P13
P4
P19
P12
P3
P10
P11
P2
P9
P9
P10
P1
P8
P36
P7
P37
P6
P5
P4
P2
P3
P1
FLUORESCENT INDICATOR TUBE
HCD-C770/C990
7-37. PRINTED WIRING BOARD – POWER Section (1/2) –
1
2
3
4
5
POWER BOARD (COMPONENT SIDE)
A
B
C
D
E
F
11
1-685-080-
68
68
(11)
HCD-C770/C990
7-38. PRINTED WIRING BOARDS – POWER Section (2/2) –
1
2
3
4
5
6
POWER BOARD (CONDUCTOR SIDE)
5
1
1
5
1
• Semiconductor
Location
Ref. No.
IC905
(US, CND)
IC908
H
1
DVD BOARD
CN008
E
2
E
(Page 42)
(AEP, UK)
5
9
3
E
B
8
(CHASSIS)
A
IC903
7
POWER SW BOARD
POWER SW BOARD
(COMPONENT SIDE)
(CONDUCTOR SIDE)
(AC IN)
1
1
5
1
IC906
2
IC904
C
A
K
A
2
1
J
E
(Page 55)
3
IC902
3
2
1
POWER
E
T901
POWER
TRANSFORMER
E
E
E
E
D-5
E-1
F-3
E-2
F-2
F-3
C-3
D-2
B-4
B-3
A-4
B-2
A-3
D-4
D-4
B-3
E-3
E-2
F-2
B-3
IC901
IC902
IC903
IC904
IC905
IC906
IC908
IC909
F-3
D-2
A-2
C-3
A-4
B-3
A-3
F-1
PC901
E-2
Q901
Q902
Q903
Q904
Q905
Q906
Q910
Q911
Q912
Q914
Q990
Q991
Q992
D-2
D-1
D-2
E-2
F-2
E-1
D-2
E-2
E-1
E-2
B-3
B-3
B-3
E
AMP BOARD
CN300
D
Location
D902
D904
D905
D906
D907
D908
D911
D912
D913
D914
D915
D916
D917
D919
D920
D921
D931
D932
D933
D990
E
E
K
E
P
DDCON
BOARD
CN807
C
A
PC901
(Page 62)
E
(AEP, AUS)
1-685-081-
IC909
11
1
5
11
IC901
1-685-080-
F
(AEP, AUS)
(US, CND)
(CHASSIS)
69
69
(11)
(11)
1-685-081-
11
(11)
HCD-C770/C990
7-39. SCHEMATIC DIAGRAM – POWER Section –
(Page 63)
CNP911
2P
D911
FML-22S
RECT
∗ F901
C913
10000p
630V
(AEP,AUS)
(AEP,AUS)
∗ C912
1000 200V
(US,CND)
R908
68k
3W
R905
68k
3W
(AEP,AUS)
POWER CONTROL
R913
2.2
(AEP,AUS)
C914
47
50V
D907
1SS133T-77
(US,CND)
D905
11EQS10
CN903
14P
VIN
(US,CND)
D912
MTZJ-T-77
-6.2B
R907
4.7k
∗
IC903
SI-8050S
REGULATOR
L907
10µH
L908
10µH
L911
10µH
∗ C919
10µH
NC
L906
10µH
6.5V
L910
10µH
Q901
DTC114EKA
E5.6V
RESET
P.CONT2
R925 180
R914
2.7k
L905
12V
P.CONT1
IC906
SI-8033JF
470p 2kV (AEP,AUS)
10µH
DVD3.3V
+3.3V
PC901
IC TLP421
2200p 1.5kV (US,CND)
L904
+6.5V REGULATOR
ISOLATOR
C916
R936
150k
C935
1000
16V
L909
100µH
820 (AEP,AUS)
REGULATOR
R911
3.9k
D921
11EQS04-TA
1B
C934
0.1
R916
+20V
∗ C916
C905
0.0047
C924
2200
35V
SWITCHING
D906
11EQS10
Q905
2SD1616
IC901
STR-F6267
GND
R915
180
1.2k
D933
11EQS10
IC908
SI-8120JF
C
IC902
SE-B2
(CHASSIS)
D932
MTZJ-T-77-22B
SW OUT
REF
+12V REGULATOR
ON/OFF
RBV-606
ON/OFF
R934
100k
GND
(US,CND)
VIN
RBV-604
390 450V
STR-F6238
(Page 56)
VOS
D920
10E6N
SW OUT
∗
RECT
EB901
12V
D902
∗ D902
C911
2200p
250V
PGND
GND
C910
2200p
250V
R900
3.3M
1/2W
C926
100p
VOS
∗
R917
2.7k
32V
PGND
VIN
C912
R930
3.3M
(US,CND)
TH901
R920
100
SW OUT
C909
2200p
250V
R919
15k
C918 0.1
∗
TRANSFORMER
R909
47k
2W
C921 2200 35V
C902
0.1
250V
F901
∗
POWER
D919
10E6N
VOS
LF901
CN902
2P
ON/OFF
C903
0.1
LF902 250V
(AEP,AUS)
CN901
2P
CN904
5P
32V
L901
10µH
C920
T901
GND
(AEP,AUS)
C923 2200 35V
C900
CN900 0.1
2P
275V
(AEP,AUS)
(US,CND)
POWER
(AC IN)
(US,CND)
4700p 630V
(AEP,AUS)
T3.15AL/250V
D908
SARS03
5A/125V
S901
∗ C920
2700p 630V
A/D
R929
10
L902 100µH
MGND
DGND
470p (US,CND)
C901
4.7
50V
C904
220p
D931
MTZJ-T-77
-20B
C919
∗
C936
0.1
1000p (AEP,AUS)
(US,CND)
R901
220
R902
0.15
1W
R903
0.15
1W
C930
0.1
D916
FMB-G16L
C931
L903
1000
100µH
10V
C942
4.7 50V
R928
10k
POWER
ON/OFF
R933
10k
CONTROL
R932
10k
GND
BUFFER
Q910
DTC114EKA
Q902,906
Q903
DTC114EKA
IC909
BA10358F
VCC
C939
2200p
POWER
Q902
DTC114EKA
ON/OFF
Q910,911
Q906
DTC114EKA
CONTROL
EB902
POWER
ON/OFF
CONTROL
(CHASSIS)
+5.6V REGULATOR
+6.8V
REGULATOR
Q992
2SC2412
R940
15k
R939
1k
R918
2.7k
R931
2.7k
C915
0.1
C941
47
16V
D904
MTZJ-T-77
-6.8B
Les composants identifiés par une marque 0 sont
critiques pour la sécurité. Ne les remplacer que
par une pièce portant le numéro spécifié.
70
VOLTAGE
DETECT
Q911
DTC114EKA
O
IC904
M51945BL
G
Q990,991
R943
1.8k
(CHASSIS)
R921
22k
BA05T
I
DETECT
R906
10k
C937
0.047
IC905
VOLTAGE
R927
1.0k
C946
0.1
R942
1k
RESET
C922
0.001
Q912
2SC2412
NC
Q914
2SC2412
Q990
2SB1640
R938
4.7k
Q904
2SC2412K
GND
R926
100k
VCC
R941
10k
IN
D917 11ES2
D990
MA111-TX
R910
4.7k
OSC
D913
MA111-TX
Q912,914
70
Q991
2SC2412
R923
10k
B+ SWITCH
C928
2200
35V
C927
0.1
D915
11ES2
C929
100
10V
C925
47
16V
R922
6.2k
R935
100k
DGND
AGND
P.CONT3
Q901,903
C938
0.001
R912
1.5k
C933
1000
10V
D914
FMB-G16L
R937 1k
C917
2200p 250V
R904
0.22
1W
R924
560
C932
0.1
(Page 53)
HCD-C770/C990
• Waveforms
– RF Board –
– DVD Board –
1 IC001 1 (DVDRFP)
qa IC401 0 (WFCK)
Approx.
400 mVp-p
qh IC401 yj (BCK)
43.4 µs
2 IC001 el (TE)
5 Vp-p
3.4 Vp-p
154 ns
qj IC401 ua (XTAI)
qs IC401 el (FE)
Approx.
50 mVp-p
Approx.
100 mVp-p
4.6 Vp-p
29.5 ns
qk IC701 <zzm (RFIN)
qd IC401 ra (TE)
3 IC001 r; (FE)
Approx.
50 mVp-p
4 IC001 tj (RFAC)
Approx.
1.2 Vp-p
Approx.
100 mVp-p
ql IC701 <zbz (WFCK)
qf IC401 t; (RFAC)
Approx.
1.2 Vp-p
Approx.
1.2 Vp-p
3.4 Vp-p
43.4 µs
w; IC701 <zb, (BCLK)
qg IC401 yg (LRCK)
5 Vp-p
3.5 Vp-p
7.4 µs
154 ns
71
HCD-C770/C990
wa IC701 <znc (LRCK)
wh IC301 ra (EXTAL)
ea IC206 <zz. (VDAC 4) (NTSC Color Bars Play)
1.6 Vp-p
3.5 Vp-p
750 mVp-p
H
50 ns
7.4 µs
ws IC701 <zm/ (XTAL1)
wj IC301 yg (TE)
es IC206 <zxx (VDAC 3) (NTSC Color Bars Play)
Approx.
100 mVp-p
3 Vp-p
750 mVp-p
H
29.5 ns
wd IC801 qa (MCKI)
wk IC301 yj (FE)
ed IC206 <zxb (VDAC 2) (NTSC Color Bars Play)
Approx.
50 mVp-p
4.5 Vp-p
850 mVp-p
H
29.5 ns
wf IC801 qd (EXCKO1)
ef IC206 <zx, (VDAC 1) (NTSC Color Bars Play)
wl IC303 3 (MO1)
900 mVp-p
4.3 Vp-p
5.3 Vp-p
H
37 ns
43 ns
wg IC801 ys (PHREFO)
e; IC303 8 (XTO)
eg IC206 <zcz (VDAC 0) (NTSC Color Bars Play)
3.7 Vp-p
5 Vp-p
1.3 Vp-p
H
354 ns
72
37 ns
HCD-C770/C990
eh IC206 <zc. (XIN)
ra IC606 wa (XOUT)
4.3 Vp-p
3.9 Vp-p
3.4 Vp-p
81 ns
37 ns
ej IC606 qd (CKOUT)
74.1 ns
rs IC612 rd (F2BCK)
81 ns
rj IC607 qf (SCKOUT)
5 Vp-p
4.4 Vp-p
rd IC612 rf (F2LRCK)
4.2 Vp-p
rk IC607 ql (LRCKO)
20.8 µs
20.8 µs
rf IC612 rl (CKOUT)
3.5 Vp-p
rl IC607 w; (BCKO)
r; IC606 w; (XMCK)
4.7 Vp-p
5 Vp-p
81 ns
20.8 µs
3.5 Vp-p
3.5 Vp-p
325 ns
el IC606 qg (LRCK)
4.6 Vp-p
81 ns
325 ns
ek IC606 qf (BCK)
325 ns
rg IC612 ts (MCK)
t; IC901 ek (X2)
1.8 Vp-p
4.2 Vp-p
4.4 Vp-p
81 ns
rh IC607 qs (MCLK2)
43 ns
50 ns
73
HCD-C770/C990
– AMP Board –
ta IC602 qd (LRCK)
ih IC300 4
ia IC305, 308, 310 rf (BCK)
20 ns
325 ns
20.8 µs
ts IC602 qf (BCK)
is IC305, 308, 310 rg (LRCK)
5.9 Vp-p
3.7 Vp-p
325 ns
20.8 µs
id IC305, 308, 310 yf (XFSIIN)
3.4 Vp-p
81 ns
if IC305 ud (FSOCKO)
3.7 Vp-p
20.8 µs
ig IC305 uj (XFSOOUT)
3.5 Vp-p
20 ns
74
3.3 Vp-p
3.6 Vp-p
6.3 Vp-p
HCD-C770/C990
– AUDIO Board –
– VIDEO Board –
– DDCON Board –
ua IC201 qf (X0)
ya IC208 qk, ql (CrOUT)
(NTSC Color Bars Play)
os Q803, 804 (Collector)
18.6 Vp-p
3.4 Vp-p
1.4 Vp-p
H
231 ns
9.1 µs
ys IC208 wa, ws (CbOUT) (NTSC Color Bars Play)
1.4 Vp-p
H
– FL Board –
yd IC208 wf, wg (CYOUT), wj, wk (YOUT)
(NTSC Color Bars Play)
oa IC802 tk (OSCO)
2.2 Vp-p
2.1 Vp-p
H
504 ns
yf IC208 e;, ea (VOUT) (NTSC Color Bars Play)
2.5 Vp-p
H
yg IC208 ed(COUT) (NTSC Color Bars Play)
1.7 Vp-p
H
75
HCD-C770/C990
• IC Block Diagrams
– RF Board –
ATOP
ATON
AIN
AIP
VPA
RFAC
BYP
DIN
DIP
FNP
FNN
VNA
MEV
RX
CXD1881AR
RFDC
RFSIN
IC001
64 63
62 61 60 59
58
57
56
55 54
53 52
51
50
49
FAST ATTACK
INPUT
SEL
DVDRFP 1
DVDRFN 2
ATT
4
MUX
INPUT
BIAS
ATT
PROGRAMMABLE
EQUALIZER
FILTER
DIFFERENTIATOR
AGC
2
INPUT
IMPEDANCE
SEL
+
CLAMP &
ENVELOPE
–
2
INPUT
IMPEDANCE
SEL
OUTPUT
FULL WAVE
INHIBIT
RECTIFER
FROM S-PORT
AGCO
CONTROL
SIGNALS
TO EACH
BLOCK
BUFFER
2
SIGDET
+
–
LEVEL
DAC
3
COMPARATOR
CE ATT
CEPOL
A2 3
PHASE
DETECTOR
B2 4
GCA
– –
–
+
TOPHOLD
3
3
FROM
FROM VC
S-PORT S-PORT
TOPHOLD
+
+
C
GCA
GCA
LPF
44 LCP
43 LCN
MNTR
CONTROL
42 MNTR
GCA
41 CE
OFFSET
CANSEL
GCA
40 FE
5
FROM
S-PORT
4
FROM
S-PORT
+
+
GCA
B
B 11
–
+
A+D
D
C 10
OFFSET
CANSEL
SDEN
SDATA
SCLK
V33
4
FROM
S-PORT
CP 7
CN 8
D 9
V33 FOR
OUTPUT
BUFFER
PI
FE
TE
CE
V25
V125
V25/3
PHASE
DETECTOR
D2 6
48
47
46
45
SERIAL
PORT
REGISTER
LPF ATT
POL SEL
BUFFER
+
+
EQ
C2 5
AGC
HOLD
AGC CHARGE
PUMP
B+C
A
A 12
MUX
GCA
3
FROM
S-PORT
MUX
GCA
LPF
CD/DVD CP/CN
LOW
IMPEDANCE
B+D
CD D 13
+
+
+
+
CD B 15
OFFSET
CANSEL
GCA
CEFDB
6
FROM
S-PORT
3
FROM
S-PORT
FOR SERVO
OUTPUT
+
+
GCA
GCA
4
FROM
S-PORT
3
FROM
S-PORT
HOLDEN
SEL
A+C
3
FROM
S-PORT
CD/DVD
39 TE
38 PI
5
FROM
S-PORT
SUM
AMP
CD A 16
TE
RST
OFFSET
CANSEL
GCA
LPF
CD C 14
GCA
W/LPF
GCA
SUB
BCA
DET
–
+
TOP
HOLD
FROM 2
DAC
S-PORT
PH
37 V25
36 V125
V25/2
35 TPH
COMPARATOR
–
+
34 DFT
GCA
SEL
33 LINK
VCI FOR SERVO INPUT
APC SEL
DVD/CD
DUAL APC
LD H/L
FROM S-PORT
76
LINKEN
HYSTERESISTER
& OFFSET
FROM S-PORT
VC = VPB/2
17 18 19 20
21 22
23
24 25 26
27
28 29
30
31
32
CD F
CD E
VPB
VC
DVDLD
CDLD
DVDPD
CDPD
VNB
LDON
MIRR
MP
MB
MLPF
MIN
MEVO
INTERNAL
FDGHG
INPUT GAIN
BOTTOM
INPUT
FROM S-PORT
AGCO
ENVELOPE
IMPEDANCE
2
MIRR
FROM S-PORT SINK CURRENT 2
COMPARATOR
2
FROM S-PORT
PH
PEAK/BOTTOM
INPUT
HOLD
BUFFER
MUX
HCD-C770/C990
– RELAY Board –
IC701, 711, 721
BA6956AN
TSD
2
3
4
5
6
7
8
9
RNF
OUT1
VM
VCC
FIN
GND
RIN
VREF
1
OUT2
CONTROL LOGIC
– DVD Board –
IC215
GND
DO
DI
BR9040F-D-E2
WC
IC203
8
7
6
5
1OE
COMMAND
REGISTER
16bit
COMMAND DECODE
CONTROL CLOCK
GENERATION
DATA
REGISTER
2
3
1
OE
LE
56 1LE
1D1
1D2
2
3
55 1Q1
54 1Q2
GND
4
53 GND
1D3
1D4
5
6
52 1Q3
51 1Q4
VCC
7
1D5
1D6
8
9
GND
10
47 GND
1D7
1D8
1D9
1D10
11
12
13
14
46
45
44
43
2D1
2D2
2D3
15
16
17
42 2Q1
41 2Q2
40 2Q3
GND
18
39 GND
2D4
2D5
2D6
19
20
21
38 2Q4
37 2Q5
36 2Q6
VCC
22
35 VCC
2D7
2D8
23
24
34 2Q7
33 2Q8
GND
25
32 GND
2D9
2D10
26
27
31 2Q9
30 2Q10
50 VCC
LATCH
49 1Q5
48 1Q6
1Q7
1Q8
1Q9
1Q10
4
SK
R/B
1
POWER
SUPPLY
VOLTAGE
DETECTOR
CS
ADDRESS
BUFFER
HIGH VOLTAGE
GENERATOR
R/W
AMP
VCC
8bit
ADDRESS
DECODER
WRITE
DISABLE
16bit
8bit
4096bit
EEPROM ARRAY
SN74ALVCH16841DGGR
2OE 28
LATCH
OE
LE
29 2LE
77
HCD-C770/C990
IC302
BR24C08F-E2
8bit
8bit
2048bit EEPROM ARRAY
8bit
A0 1
A1 2
A2 3
DATA
REGISTER
STOP
SLAVE/ WORD
ADDRESS REGISTER
START
ADDRESS
DECODER
8
Vcc
7
TEST
6
SCL
5
SDA
CONTROL CIRCUIT
ACK
GND 4
HIGH–VOLTAGE
GENERATOR
V16M
VCTL
BIAS
AVDD1
PCO
FILI
FILO
CLTV
AVSS1
RFAC
ASYI
ASYO
AVDD0
IGEN
AVSS0
ADIO
RFDC
CE
TE
CXD3068Q
VPCO
60
59 58
57 56 55 54 53 52
51 50 49 48
47 46 45 44 43 42 41
DVDD2 61
ASYE 62
MD2 63
OSC
DIGITAL
OUT
DOUT 64
LRCK 65
PCMD 66
BCK 67
D/A DIGITAL
INTERFACE
EFM
DEMODULATOR
32K
RAM
EMPH
XTSL
DVSS2
XTAI
XTAO
ASYMMETRY
CORRECTOR
68
69
70
71
72
ERROR
CORRECTOR
CLOCK
GENERATOR
TRACKING
PWM
GENERATOR
SLED
PWM
GENERATOR
76
77
78
79
80
6
7
8 9 10 11 12 13 14 15 16 17 18 19 20
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2PO
SCOR
C4M
WDCK
DVSS0
COUT
MIRR
DATA
5
SENS
4
XLAT
3
CLOK
2
XRST
DVDD0
1
MUTE
CPU
INTERFACE
40
39
38
37
36
35
34
SE
TE
VC
TES1
TEST1
DVSS1
FRDR
33 FFDR
32 TRDR
31 TFDR
30 SRDR
29 SFDR
28 DVDD1
27 FSTO
26 SSTP
SERVO INTERFACE
SERVO
AUTO
SEQUENCER
78
FOCUS
PWM
GENERATOR
SUBCODE
PROCESSOR
SOUT 73
SOCK 74
XOLT 75
SQSO
SQCK
SCSY
SBSO
EXCK
FOCUS
SERVO
DSP
TRACKING
SERVO
DSP
SLED
SERVO
DSP
OPERATIONAL
AMPLIFIER &
ANALOG SWITCH
DIGITAL
PLL
A/D
CONVERTER
IC401
POWER SUPPLY
VOLTAGE DETECTOR
DIGITAL
CLV
PROCESSOR
25 MDP
24 LOCK
23 PWMI
MIRR, DFCT,
FOK
DETECTOR
22 FOK
21 DFCT
HCD-C770/C990
VCC
C PR
C NR
C PR
C NR
VDD
DGND
SYSCLK
DOUT
BCK
LRCK
PCM1800E/2K
AGND
IC602
24
23
22
21
20
19
18
17
16
15 14 13
DIGITAL ∑
MODULATOR
1/64
DECIMATION
FILTER
&
LOW-CUT
FILTER
RIN
MODE0
MODE1
FSYNC
V REF 2
10 11 12
5
IDT71V016S15PH-AUTL
18
19
20
21
22
44 A5
43 A6
42 A7
ROW/COLUMN
DECODER
OUTPUT ENABLE
BUFFER
64K x 16
MEMORY
ARRAY
CHIP ENABLE
BUFFER
7
8
9
10
11
12
13
14
15
16
WE 17
A15
A14
A13
A12
NC
7 8 9
4
1
2
3
4
5
CS 6
I/O 0
I/O 1
I/O 2
I/O 3
VDD
VSS
I/O 4
I/O 5
I/O 6
I/O 7
6
3
V REF 1
LIN
A4
A3
A2
A1
A0
CLOCK/
TIMING CONTROL RESET/
POWER CONTROL
2
1
IC604
SINGLE-END
DEFERENTIAL
CONVERTER
REFCOM
REFERENCE
BYPASS
FMT0
FMT1
SINGLE-END
DEFERENTIAL
CONVERTER
RSTB
DIGITAL ∑
MODULATOR
SERIAL I/O
INTERFACE
&
MODE/FORMAT
CONTROL
WRITE ENABLE
BUFFER
LOW
BYTE
I/O
BUFFER
SENSE AMP
&
WRITE
PRIVER
BYTE ENABLE
BUFFER
HIGH
BYTE
I/O
BUFFER
41 OE
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
BHE
BLE
I/O 15
I/O 14
I/O 13
I/O 12
VSS
VDD
I/O 11
I/O 10
I/O 9
I/O 8
NC
A8
A9
A10
A11
NC
79
HCD-C770/C990
XSEL
VF
F2
F1
F0
CSFLAG
LC89056W-E
DI
DO
ERROR
BPSYNC
ERR9P
DGND
IC606
36 35 34 33 32 31
30
29 28 27 26 25
C BIT
DETECT
CE 37
CL 38
XSEL 39
MODE0 40
24 AUDIO
23 EMPHA
PA/PB
DETECT
SAMPLING
FREQUENCY
MICROCOMPUTER
INTERFACE
MODE1 41
DGND 42
DVDD 43
LOCK
DETECT
DOSEL0 44
DOSEL1 45
22
21
20
19
18
17
16
15
14
13
X’ TAL
DATA
DEMODULATOR
TIMING
CKSEL0 46
CKSEL1 47
IC608
MCLK
PLL
DOUT
DINO
DINI
5
6 7
8 9 10
R
VIN
LPF
4
DIN2
2 3
DGND
DVDD
1
DISEL
INPUT
CIRCUIT
11 12
AVDD
AGND
XMODE 48
AK4382AVT-E2
CLOCK
DIVIDER
1
16 DZFL
15 DZFR
DE–EMPHASIS
CONTROL
14 VDD
13 VSS
BICK
SDTI
LRCK
2
3
4
PDN
5
CSN
CCLK
CDTI
6
7
8
80
AUDIO
DATA
INTERFACE
µP
INTERFACE
8x
INTERPOLATOR
∆∑
MODULATOR
SCF
12 AOUTL+
11 AOUTL–
8x
INTERPOLATOR
∆∑
MODULATOR
SCF
10 AOUTR+
9 AOUTR–
XIN
XOUT
XMCK
DVDD
DGND
XSTATE
DATAO
LRCK
BCK
CKOUT
HCD-C770/C990
MCK
VDD5
VSS5
CKOUT
TEST1
F2FLREX1
F2CSWEX2
F2SLR
F2LRCK
F2BCK
FMT2FS
VDD4
54 53
52
51 50
49
48
47 46
45
44 43
42
41
59 58 57 56 55
TEST3
EXILRCK
EXIBCK
EXIMCK
60
EXID1
EXID2
TEST2
CXD9633Q
VSS6
IC612
2FS I/F
TEST/MONITOR
CONTROL
2FS
EXT.
DATA
SELECT
VDD6 61
DSBCKF 62
DSIFL
DSIFR
DSICT
DSISW
DSISL
DSISR
63
64
65
66
67
68
2FS
EXT.
CLOCK
SELECT
FL
FR
CT
SW
SL
SR
40 VSS4
39 DIR2CK
CLOCK
GENERATOR
&
TIMING
CONTROL
DIRDSCK1 69
DIRDSCK2 70
INTERNAL
CLOCK
SR
SL
SW
CT
FR
FL
CK
CKB
WCK
BCK
38 SELDH1
37 SELDH2
FL
FR
CT
SELRAM 71
FIR FILTER
&
DOWN
SAMPLING
UNIT
SELFIR1 72
SELFIR2 73
SW
PCM
MUTE
36
35
34
33
8FS
I/F
8FS
SW/SB
SELECT
32 F8BL
31 VDD3
SL
SR
30 VSS3
29 F8BR
28 F8SL
27 F8SR
COEF. SELECT
RAM
29bit x 240
ROM
24bit x 720
XMTPCM 74
CT
FR
FL
SW
SR
SL
CKB
WCK
BCK
CK
SEL8FS 76
SELEXT 77
INTERNAL
CONTROL
VSS7 80
26 F8WCK
25 F8BCK
24 FMT8WCK
23 FMT8FS
DSD MUTE
XMTDSD 75
SYNC 78
INIT 79
F8FL
F8FR
F8CT
F8SW
22 DIR8CK
21 VDD2
DSD
SW/SB
SELECT
SELSBSW
SELSBR
10
11
12 13 14 15 16 17 18 19
20
VSS2
DSGAIN
9
DSOSR
DSOSL
DSOBR
DSOBL
DSOSW
DSOCT
DSOFR
DSOFL
MSHIFT
MLATCH
MDATA
8
DSBCKB
6 7
VSS1
5
SELMCU
2 3 4
MONTOR
1
VDD1
CPU I/F
CONTROL
81
HCD-C770/C990
40 – 36
35 34 33
TIMING
GENERATOR
REFRESH
CONTROL
CLOCK
VSS
44 43 42 41
A9
A8
A7
A6
A5
A4
45
OE
DQ12
DQ11
DQ10
DQ9
49 48 47 46
UCAS
VSS
NC
50
LCAS
DQ16
DQ15
DQ14
DQ13
MSM51V18165F-60TSKR1
VSS
IC706
32 31 30 29 28 27
26
INTERNAL
ADDRESS
COUNTER
I/O
CONTROLLER
SENSE
AMPLIFIER
COLUMN
DECODERS
MEMORY
CELLS
VCC
1
2 3 4 5
6
7 8 9 10
11 – 16
17 18
VCC
DQ1
DQ2
DQ3
DQ4
VCC
DQ5
DQ6
DQ7
DQ8
NC
WE
RAS
VCC
ON CHIP
VBB GENERATOR
VCC
ON CHIP
IVCC GENERATOR
VCC
VCC
19 20
21 22 23 24
25
DQ16
DQ15
VSSQ
DQ14
DQ13
VCCQ
DQ12
DQ11
VSSQ
DQ10
DQ9
VCCQ
NC
UDQM
CLK
CKE
NC
A9
A8
A7
A6
A5
A4
VSS
MSM56V16160F-8TK7R1
VSS
IC808
ROW
DECODERS
WORD
DRIVERS
VCC
INPUT
BUFFER
ROW
ADDRESS
BUFFERS
COLUMN
ADDRESS
BUFFERS
I/O
SELECTOR
OUTPUT
BUFFER
I/O
CONTROLLER
A0
A1
A2
A3
INPUT
BUFFER
NC
NC
OUTPUT
BUFFER
50
49 48
47
46 45
44
43 42
41
40 39
38
37
36 35 34
33
32 31 30 29 28 27
26
TIMING
REGISTER
OUTPUT
BUFFERS
PROGRAMING
REGISTER
READ
DATA
REGISTER
LATENCY
&
BURST
CONTROLLER
INTERNAL
COLUMN
ADDRESS
COUNTOR
ROW
ADDRESS
BUFFERS
INTERNAL
ROW
ADDRESS
COUNTOR
I/O
CONTROLLER
INPUT
DATA
REGISTER
SENSE
AMPLIFIER
COLUMN
DECODERS
BANK
CONTROLLER
INPUT
BUFFERS
2 3
4
5 6
7
8 9
10
11 12
13
14 15 16 17 18
19 20 21 22 23 24
25
DQ3
DQ4
VCCQ
DQ5
DQ6
VSSQ
DQ7
DQ8
VCCQ
LDQM
WE
CAS
A11
A10
A0
A1
A2
A3
VCC
RAS
CS
1
VSSQ
ROW
DECODERS
DQ1
DQ2
WORD
DRIVERS
VCC
MEMORY
CELLS
82
COLUMN
ADDRESS
BUFFERS
HCD-C770/C990
– AMP Board –
IC814
TC7WH157FK (TE85R)
8 VCC
11
7 ST
11
6 SELECT
A 1
A
Y
B 2
B
Y
GND 4
VBBA 1
CXD9702L
VBBA
VBOOTA 2
VDRVA 3
VDRVA
UNDER
VOLTAGE
LOCK–OUT
VDDA 4
EN G
Y 3
IC301, 304, 306, 307, 309, 311
5
Y
GNDA 5
THERMAL
SHUT DOWN
INA 6
ENA 7
DIAGA 8
PROTECTOR
CIRCUIT
CROSS OVER
DELAY
LOW SIDE
LEVEL SHIFT
HIGH SIDE
LEVEL SHIFT
PRE
DRIVER
PRE
DRIVER
FILTER
+
−
+
−
VBBA
VDRVA
VBBA
OUTA 9
SA 10
VBBB 11
VBBB
VBOOTB 12
VDRVB 13
VDRVB
UNDER
VOLTAGE
LOCK–OUT
VDDB 14
GNDB 15
THERMAL
SHUT DOWN
INB 16
ENB 17
DIAGB 18
PROTECTOR
CIRCUIT
CROSS OVER
DELAY
LOW SIDE
LEVEL SHIFT
HIGH SIDE
LEVEL SHIFT
PRE
DRIVER
PRE
DRIVER
FILTER
+
−
+
−
VBBB
VDRVB
VBBB
OUTB 19
SB 20
83
HCD-C770/C990
BFVSS
CKO3
CKO2
CKO1
DVSS
FSOI
FSOCKO
SFLAG
OFLFLAG
OUTSEL
78 77 76
DVDD
79
XOVDD
XOVSS
80
XFSOUT
VSUBCR
CXD9634Q
VSSR2+
IC305, 308, 310
75 74 73 72 71 70 69 68 67 66 65
OUTR2+
1
VDDR2+
2
VDDR2–
3
OUTR2–
4
64 XFSIIN
SYNC
XFSIIN
FSII
MCKSEL
CKCTL2
CKCTL1
XFSIIN
CLOCK
GENERATOR
(PRIMARY)
CLOCK
GENERATOR
(SECONDARY)
CXWCK
EXBCK
EXDATAR
EXDATAL
VSSR2–
5
VSSR1–
6
63
62
61
60
59 EXIOSEL
OUTR1–
7
VDDR1–
8
VDDR1+
9
SgP
58 BFVDD
CKCTL2
CKCTL1
57 CKCTL2
56 CKCTL1
OUTR1+ 10
55 TEST2
54 TEST1
VSSR1+ 11
VWELR 12
VWELL 13
53 DSDCKIO
52 DSDCKSEL2
51 DSDCKSEL1
PWM
/THROUGH
VSSL2+ 14
DOWN
SAMPLING
FILTER
OUTL2+ 15
VDDL2+ 16
∆∑
VDDL2– 17
LINER
INTERPOLATOR
(2 TIMES)
GAIN
CONTROL
RATE
CONVERTER
FSII
50
49
48
47
DSDL
DSDR
DSD64FS
DSD128FS
46 FSII
OUTL2– 18
45 LRCK
44 BCK
43 DATA
VSSL2– 19
SgP
VSSL1– 20
OUTL1– 21
MCKSEL
SYNC
42 SYNC
VDDL1– 22
VDDL1+ 23
84
27
28
29 30 31
32
33
34 35
36 37 38
39
40
VSUBX
MCKSEL
DVDD
MODE1
MODE2
SCLATCH
SCSHIFT
SCDT
NSPMUTE
PGMUTE
DVSS
26
XVSS
25
XFSOIN
41 INIT
XVDD
INIT/
MUTE
XSUBCL
SERIAL
CONTROL
VSSL1+
OUTL1+ 24
HCD-C770/C990
– AUDIO Board –
IC202
VDD2
14
13
12 11 10
DIGITAL
CLOCK
T2
XI
15
T1
XO
16
VSS2
NC
BU1924F-E2 (AEP only)
RCLK
IC201
2
2XCOM
3
14 X1
2X3
4
13 XCOM
15 X2
12 X0
INH
6
11 X3
VEE
7
10 A
VSS
8
9
B
3
4
5
6
7
8
VDD1
VSS1
VSS3
CMP
ANALOG
2
MUX
ANTI-ALIASING
FILTER
VREF
DEFFERENTIAL
DECODER
2X2
2X1 5
RDAT
QUAL
1
BIPHASE
DECODER
1
TEST
COMPARATOR
8th SWITCHED
CAPACITOR
FILTER
16 VDD
2X0
9
PLL 57kHz
RDS/ARI
PLL
1187.5Hz
MC14052 BDR2
– VIDEO Board –
IC206
MM1510
6 PS
SAG 1
OUT 2
IC208
DRIVER
VCC1
MM1568
1
CIN
2
MUTE1
3
VIN
4
4dB
LPF
4dB
LPF
2dB
75Ω
DRIVER
2dB
75Ω
DRIVER
5 GND
CLAMP
VCC 3
34 VCC2
BIAS
4 IN
BIAS
CLAMP
32 GND2
+
YC MIX
33 COUT
31 VOUT
5
30 VSAG
CLAMP
IC207
NJM2235V (TE2)
YIN
6
BIAS
7
GND1
8
NC
9
29 GND2
LPF
4dB
2dB
75Ω
DRIVER
28 YOUT
BIAS
27 YSAG
GND1 10
8 GND
VIN 1 1
BUFFER
7 V OUT
NC 11
26 GND2
CYIN 12
4dB
LPF
2dB
SW 1 2
CLP 13
VIN 2 3
75Ω
DRIVER
24 CYSAG
BIAS
CLAMP
23 GND2
BIAS
SW 2 4
25 CYOUT
CbIN 14
6 V+
MUTE2 15
4dB
LPF
BIAS
2dB
75Ω
DRIVER
5 VIN 3
22 CbOUT
21 CbSAG
CrIN 16
GND2 17
4dB
BIAS
20 GND2
LPF
2dB
75Ω
DRIVER
19 CrOUT
18 CrSAG
85
HCD-C770/C990
– FL Board –
IC802
MSM9202-05GS-KDR1
P1
P2
1
2
PORT
DRIVER
AD2
AD1
3
4
AD
DRIVER
ADRAM
2bit x 16
ADDRESS
SELECTOR
64 VDD
WRITE
ADDRESS
COUNTER
READ
ADDRESS
COUNTER
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
86
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
COMMAND
DECODER
8bit
SHIFT
REGISTER
CONTROL
CIRCUIT
TIMING
GENERATOR2
63 DA
62 CP
61 CS
60 RESET
TIMING
GENERATOR1
OSCILLATOR
59 OSC1
58 OSC0
57 GND
56 VFL
DIGIT
CONTROL
GRID
DRIVER
DUTY
CONTROL
SEGMENT
DRIVER
CGROM
35bit x 248
CGRAM
35bit x 8
DCRAM
8bit x 16
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
COM16
COM15
COM14
COM13
COM12
COM11
COM10
COM9
COM8
COM7
COM6
COM5
COM4
COM3
COM2
COM1
39
38
37
36
35
34
33
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
HCD-C770/C990
– POWER Board –
IC901 STR-F6238 (US, Canadian), STR-F6267S (AEP, Australian)
DRIVE
REGULATOR
OVER
CURRENT
PROTECTOR
OVER
VOLTAGE
PROTECTOR
INH1
LATCH
START
THERMAL
SHUT DOWN
FEED BACK
INH2
OSC
OVER LOAD
PROTECTOR
REGULATOR
DRIVE
3
4
5
VIN
F.B
SI-8050S-LF1101
IC904
1.25V
3
4
5
S.S
IC908
OVER
CURRENT
PROTECTOR
5
+
–
NC
OUTPUT
OVER
CURRENT
PROTECTOR
LATCH
&
DRIVER
ON/OFF
SOFT
START
OVER HEAT
PROTECTOR
OSC
COMPARATOR
+
–
+
–
VREF
ERROR AMP
LATCH
&
DRIVER
RESET
OVER HEAT
PROTECTOR
VREF
1
2
3
4
5
1
2
3
VIN
SW OUT
GND
VOS
ON/OFF
VIN
SW OUT
GND
ERROR AMP
4
5
VOS
COMPARATOR
+
–
SI-8120JF
REGULATOR
RESET
OSC
4
ON/OFF
VIN
2
SI-8033JF
ON/OFF
SOFT
START
3
VREF
1
REGULATOR
2
GND
+
–
ERROR AMP
1
INPUT
COMPARATOR
OVER HEAT
PROTECTOR
SUPPLY
VOLTAGE
LATCH
&
DRIVER
RESET
VOS
+
–
–
+
GND
OSC
IC906
M51945BL
OVER
CURRENT
PROTECTOR
REGULATOR
SW OUT
IC903
2
D
O.C.P
1
GND
CURRENT
MIRROR
87
HCD-C770/C990
7-40.
IC PIN FUNCTION DESCRIPTION
• DVD BOARD IC301 CXP973064-220R (MACHANISM CONTROLLER)
Pin No.
Pin Name
I/O
Description
1
EEP SO
O
Not used
2
SDEN
O
Serial data enable signal output to DVD/CD RF amplifier
3
DOCTRL/
ISBTEST
O
Digital out on/off control signal output to the digital signal processor
“L”: digital out off, “H”: digital out on
4
EEP WC
O
Not used
5
EEP SI
I/O
Two-way data bus with the EEPROM
6
EEP RDY
I
EEPROM ready signal input from the DVD decoder
7
FCS JMP 1
O
Focus jump 1 signal output to the motor/coil driver
8
FCS JMP 2
O
Focus jump 2 signal output to the motor/coil driver
9
SENS CD
I
Internal status (SENSE) signal input from the digital signal processor
10
LOAD +
O
Loading motor drive signal (loading in direction) output terminal
11
LOAD –
O
Loading motor drive signal (loading out direction) output terminal
12
XCS DVD
O
Chip select signal output to the DVD decoder
13
VSS
—
Ground terminal (digital system)
14 to 21
D0 to D7
I/O
Two-way data bus with the DVD decoder
22
INIT0 DVD
I
Interrupt signal input from the DVD decoder
23
INIT1 DVD
I
Interrupt signal input from the DVD decoder
24
SCK DSD
O
Serial data transfer clock signal output to the DSD decoder
25
XRST DVD
O
Reset signal output to the DVD decoder
26
SCOR
I
Subcode sync (S0+S1) detection signal input from the digital signal processor
27
LAT CD
O
Serial data latch pulse signal output to the digital signal processor
28
LD ON
O
Laser diode on/off control signal output to the DVD/CD RF amplifier
“L”: laser diode off, “H”: laser diode on
29
MIRR
I
Mirror signal input from the digital signal processor
30
COUT CD
I
Numbers of track counted signal input from the digital signal processor
31
INLIM
I
Detection signal input from limit in switch
32
CS ZIVA
O
Chip select signal output to the DVD system processor
33
SI ZIVA
I
Serial data input from the DVD system processor
34
SO ZIVA
O
Serial data output to the DVD system processor
35
Serial data transfer clock signal output to the DVD system processor
Not used
Not used
“L”: reset
The optical pick-up is inner position when “H”
SCK ZIVA
O
36
DRVIRQ
O
Interrupt request signal output to the DVD system processor
37
DRVRDY
O
Ready signal output to the DVD system processor
38
RST
I
System reset signal input from the DVD system processor
39
VSS
—
40
XTAL
I
System clock input terminal (20 MHz)
41
EXTAL
O
System clock output terminal (20 MHz)
“L”: reset
42
VDD
—
Power supply terminal (+3.3V) (digital system)
43, 44
SLED A, SLED B
O
Sled motor drive signal output
45
JIT OFFSET
O
Output terminal for offset adjustment of APEO (<z/. pin of DVD decoder)
46
SDOUT DSD
O
Serial data output to the DSD decoder
47
SDIN DSD
I
Serial data input from the DSD decoder
48
READY DSD
I
Ready signal input from the DSD decoder
49
DATA CD
O
Serial data output to the digital signal processor
50
CLOK CD
O
Serial data transfer clock signal output to the digital signal processor
51
XMSLAT
O
Serial data latch pulse signal output to the DSD decoder
52
SQSO
I
Subcode Q data input from the digital signal processor
88
“L”: ready
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
53
MUTE DSD
O
Muting on/off control signal output to the DSD decoder
54
SQCK
O
Subcode Q data reading clock signal output to the digital signal processor
55
VSS
—
56
TRAY IN
I
Disc tray in detection signal input terminal
57
TRAY OUT
I
Disc tray out detection signal input terminal
“H”: muting on
Not used
Not used
58
GFS DVD
I
Guard frame sync signal input from the DVD decoder
59
MUTE CD
O
Muting on/off control signal output to the digital signal processor
60
MUTE 2D
O
Muting on/off control signal output to the motor/coil driver
61
SLED
I
Sled motor servo drive PWM signal input terminal
62
FG
I
Spindle motor control signal input
63
SP ON
O
Muting on/off control signal output to the motor/coil driver
64
JIT
I
Jitter signal input
65
TE
I
Tracking error signal input from the DVD/CD RF amplifier
66
PI
I
Pull in signal input from the DVD/CD RF amplifier
67
FE
I
Focus error signal input from the DVD/CD RF amplifier
68
AVSS
—
69
AVREF
I
70
AVDD
—
71
GFS CD
I
Guard frame sync signal input from the digital signal processor
72
SCLK CD
O
SENSE serial data reading clock signal output to the digital signal processor
73
TSD
O
Thermal shut down signal output to the motor/coil driver
74
FOK CD
I
Focus OK signal input from the digital signal processor
75
LOCK CD
I
GFS is sampled by 460 Hz
76
LDSEL
O
Laser diode selection signal output
77
SACD/DVD
O
SACD/DVD selection signal output
78
I2C SIO
I/O
Communication data bus with the DVD system processor and system controller
79
IIC-CLK
I/O
Communication data reading clock signal input or transfer clock signal output with the DVD
system processor and system controller
80
RXD
I
Serial data input from the RS-232C (for check)
81
TXD
O
Serial data output to the RS-232C (for check)
82
SDCLK RF
O
Serial data transfer clock signal output to the DVD/CD RF amplifier
83
SDATA RF
I/O
Two-way data bus with the DVD/CD RF amplifier
84
XWR
O
Write strobe signal output to the DVD decoder
“H”: muting on
“H”: muting on
“H”: muting on
Ground terminal (for A/D converter)
Reference voltage input terminal (for A/D converter)
Power supply terminal (+3.3V) (for A/D converter)
“H” input when GFS is “H”
“L”: DVD, “H”: SACD
85
XRD
O
Read strobe signal output to the DVD decoder
86
(PWE)
—
Not used
87
VDD
—
88
VSS
—
89 to 96
A0 to A7
O
Address signal output to the DVD decoder
97
DSAVE
O
Motor/coil driver power save control signal output terminal
98
XDRST
O
Reset signal output to the digital signal processor and DSD decoder
99
EEP WP
O
Write protect signal output to the EEPROM
100
EEP CLK
O
Clock signal output to the EEPROM
Not used
“L”: reset
89
HCD-C770/C990
• DVD BOARD IC401 CXD3068Q (DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR)
Pin No.
Pin Name
I/O
1
DVDD0
—
2
XRST
I
Reset signal input from the mechanism controller
3
MUTE
I
Muting on/off control signal input from the mechanism controller
4
DATA
I
Serial data input from the mechanism controller
5
XLAT
I
Serial data latch pulse signal input from the mechanism controller
6
CLOK
I
Serial data transfer clock signal input from the mechanism controller
7
SENS
O
Internal status (SENSE) signal output to the mechanism controller
8
SCLK
I
SENSE serial data reading clock signal input from the mechanism controller
90
Description
“L”: reset
9
ATSK
I/O
Input/output terminal for anti-shock
10
WFCK
O
Write frame clock signal output to the DVD decoder
11
RFCK
O
RFCK signal output terminal
Not used
12
XPCK
O
XPCK signal output terminal
Not used
“H”: muting on
Not used
13
GFS
O
Guard frame sync signal output to the mechanism controller
14
C2PO
O
C2 pointer signal output to the DVD decoder
15
SCOR
O
Subcode sync (S0+S1) detection signal output to the DVD decoder and mechanism controller
16
C4M
O
4.2336 MHz clock signal output terminal
17
WDCK
O
Guard subcode sync (S0+S1) detection signal output to the DVD decoder
18
DVSS0
—
19
COUT
O
Numbers of track counted signal output to the mechanism controller
20
MIRR
O
Mirror signal output to the mechanism controller
21
DFCT
I/O
Defect signal input/output terminal
22
FOK
O
Focus OK signal output to the mechanism controller
23
PWMI
I
Spindle motor external control signal input terminal
24
LOCK
O
GFS is sampled by 460 Hz
25
MDP
O
Spindle motor servo drive signal output to the DVD decoder
26
SSTP
I
Detection signal input from limit in switch
Not used
Not used
Not used
“H” output when GFS is “H”
The optical pick-up is inner position when “H”
27
FSTO
O
2/3 divider output terminal
28
DVDD1
—
29
SFDR
O
Sled servo drive PWM signal (+) output
30
SRDR
O
Sled servo drive PWM signal (–) output
31
TFDR
O
Tracking servo drive PWM signal (+) output
32
TRDR
O
Tracking servo drive PWM signal (–) output
33
FFDR
O
Focus servo drive PWM signal (+) output
Not used
34
FRDR
O
Focus servo drive PWM signal (–) output
35
DVSS1
—
36
TEST
I
Input terminal for the test
37
TES1
I
Input terminal for the test
38
VC
I
Middle point voltage (+1.65V) input terminal
39
FE
I
Focus error signal input from the DVD/CD RF amplifier
40
SE
I
Sled error signal input from the DVD/CD RF amplifier
41
TE
I
Tracking error signal input from the DVD/CD RF amplifier
42
CE
I
Middle point servo analog signal input
43
RFDC
I
RF signal input from the DVD/CD RF amplifier
44
ADIO
O
Output terminal for the test
45
AVSS0
—
Ground terminal (analog system)
46
IGEN
I
Not used
Stabilized current input for operational amplifiers
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
47
AVDD0
—
Power supply terminal (+3.3V) (analog system)
48
ASYO
O
EFM full-swing output terminal
49
ASYI
I
Asymmetry comparator voltage input terminal
50
RFAC
I
EFM signal input from the DVD/CD RF amplifier
51
AVSS1
—
52
CLTV
I
Internal VCO control voltage input terminal
53
FILO
O
Filter output for master PLL
54
FILI
I
Filter input for master PLL
55
PCO
O
Charge pump output for master PLL
56
AVDD1
—
57
BIAS
I
Asymmetry circuit constant current input terminal
58
VCTL
I
VCO control voltage input terminal for the wideband EFM PLL
59
V16M
O
VCO oscillation output terminal for the wideband EFM PLL
Not used
Not used
60
VPCO
O
Charge pump output terminal for the wideband EFM PLL
61
DVDD2
—
62
ASYE
I
Asymmetry circuit on/off control signal input terminal
63
MD2
I
Digital out on/off control signal input from the mechanism controller
“L”: digital out off, “H”: digital out on
64
DOUT
O
Digital audio signal output to the digital audio interface IC
65
LRCK
O
L/R sampling clock signal (44.1 kHz) output to the DVD decoder
66
PCMD
O
Serial data output to the DVD decoder
67
BCLK
O
Bit clock signal (2.8224 MHz) output to the DVD decoder
68
EMPH
O
“L” is output when playback disc is emphasis off
“H” is output when playback disc is emphasis on Not used
69
XTSL
I
Input terminal for the system clock frequency setting
“L”: 16.9344 MHz, “H”: 33.8688MHz Fixed at “H” in this set
70
DVSS2
—
71
XTAI
I
System clock input terminal (33.8688 MHz)
72
XTAO
O
System clock output terminal (33.8688 MHz)
73
SOUT
O
Serial data output terminal
74
SOCK
O
Serial data reading clock signal output terminal
75
XOLT
O
Serial data latch pulse signal output terminal
76
SQSO
O
Subcode Q data output to the mechanism controller
77
SQCK
I
Subcode Q data reading clock signal input from the mechanism controller
78
SCSY
I
Input terminal for resynchronism of guard subcode sync (S0+S1)
79
SBSO
O
Subcode serial data output to the DVD decoder
80
EXCK
I
Subcode serial data reading clock signal input to the DVD decoder
Not used
“L”: off, “H”: on
Not used
Not used
Not used
Not used
Not used
Not used
91
HCD-C770/C990
• DVD BOARD IC607 CXD9617R (AUDIO DIGITAL SIGNAL PROCESSOR)
Pin No.
Pin Name
I/O
1
VSS
—
Description
2
XRST
I
Reset signal input from the system controller
3
EXTIN
I
Master clock signal input terminal
4
FS2
I
Sampling frequency selection signal input terminal
5
VDDI
—
6
FS1
I
Sampling frequency selection signal input terminal
7
PLOCK
O
Internal PLL lock signal output terminal
8
VSS
—
Ground terminal
9
MCLK1
I
10
VDDI
—
Power supply terminal (+2.6V)
11
VSS
—
Ground terminal
12
MCLK2
O
System clock signal output terminal (13.5 MHz)
Master/slave selection signal input terminal
Ground terminal
“L”: reset
Not used
Not used
Not used
Not used
System clock signal input terminal (13.5 MHz)
13
MS
I
14
SCKOUT
O
Internal system clock signal output to the D/A converter and stream processor
15
LRCKI1
I
L/R sampling clock signal (44.1 kHz) input from the digital audio processor
16
VDDE
—
17
BCKI1
I
Bit clock signal (2.8224 MHz) input from the digital audio processor
18
SDI1
I
Front L-ch and R-ch audio serial data input from the digital audio processor
19
LRCKO
O
L/R sampling clock signal (44.1 kHz) output to the D/A converter and stream processor
20
BCKO
O
Bit clock signal (2.8224 MHz) output to the D/A converter and stream processor
21
VSS
—
Ground terminal
22
KFSIO
I
Audio clock signal (11.2896 MHz) input from the digital audio processor
23
SDO1
O
Front L-ch and R-ch audio serial data output to the stream processor
24
SDO2
O
Center and woofer audio serial data output to the stream processor
25
SDO3
O
Rear L-ch and R-ch audio serial data output to the stream processor
26
SDO4
O
Audio serial data output to the D/A converter
27
SPDIF
O
S/PDIF signal output terminal
28
LRCKI2
I
L/R sampling clock signal (44.1 kHz) input from the A/D converter
29
BCKI2
I
Bit clock signal (2.8224 MHz) input from the A/D converter
30
SDI2
I
Center and woofer audio serial data input from the digital audio processor
31
VSS
—
32
HACN
O
Acknowledge signal output to the system controller
33
HDIN
I
Write data input from the system controller
34
HCLK
I
Clock signal input from the system controller
35
HDOUT
O
Read data output to the system controller
36
HCS
I
Chip select signal input from the system controller
37
SDCLK
O
Clock signal output terminal
38
CLKEN
O
Clock enable signal output terminal
39
RAS
O
Row address strobe signal output terminal
40
VDDI
—
41
VSS
—
Ground terminal
42
CAS
O
Column address strobe signal output terminal
43
DQM
O
Output terminal of data input/output mask
Not used
Ground terminal
Not used
Not used
44
CS0
O
Chip select signal output to the S-RAM
45
WE0
O
Write enable signal output to the S-RAM
92
“L”: slave, “H”: master (fixed at “L” in this set)
Not used
Not used
Not used
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
46
VDDE
—
47
WMD1
I
48
VSS
—
49
WMD0
I
S-RAM wait mode setting terminal
50
PAGE2
O
Page selection signal output terminal
51
VSS
—
Ground terminal
52, 53
PAGE1, PAGE0
O
Page selection signal output terminal
54
BOOT
I
Boot mode control signal input terminal
55
BTACT
O
Boot mode state display signal output terminal
56
BST
I
Boot trap signal input from the system controller
57
MOD1
I
PLL input frequency selection signal input terminal
“L”: 384fs, “H”: 256fs (fixed at “H” in this set)
58
MOD0
I
Mode setting terminal
59
EXLOCK
I
PLL lock error and data error flag input from the digital audio interface IC
60
VDDI
—
61
VSS
—
Ground terminal
S-RAM wait mode setting terminal
Fixed at “H” in this set
Ground terminal
Fixed at “L” in this set
Not used
Not used
Not used
Not used
“L”: single chip mode, “H”: use prohibition (fixed at “L” in this set)
62, 63
A17, A16
O
Address signal output terminal
64 to 66
A15 to A13
O
Address signal output to the S-RAM
67
GP10
O
L/R sampling clock signal (44.1 kHz) output to the D/A converter and stream processor
68
GP9
O
Decode signal output to the system controller
69
GP8
I
Bit 1 input terminal of channel status from the digital audio interface IC
70
VDDI
—
Not used
71
VSS
—
Ground terminal
72 to 75
D15 to D12
I/O
Two-way data bus with the S-RAM
76
VDDE
—
77 to 80
D11 to D8
I/O
81
VSS
—
Ground terminal
82 to 85
A9, A12 to A10
O
86
TDO
O
Simple emulation data output terminal
87
TMS
I
Simple emulation data input start/end detection signal input terminal
88
XTRST
I
Simple emulation asychronous break input terminal
89
TCK
I
Simple emulation clock signal input terminal
90
TDI
I
Simple emulation data input terminal
91
VSS
—
Ground terminal
92 to 97
A8 to A3
O
98, 99
D7, D6
I/O
100
VDDI
—
101
VSS
—
Ground terminal
102 to 105
D5 to D2
I/O
106
VDDE
—
107, 108
D1, D0
I/O
109, 110
A2, A1
O
111
VSS
—
Ground terminal
112
A0
O
113
PM
I
PLL reset signal input from the system controller
114
SDI3
I
Rear L-ch and R-ch audio serial data input from the digital audio processor
Not used
Not used
Not used
Not used
Not used
“L”: reset
93
HCD-C770/C990
Pin No.
Pin Name
I/O
115
SDI4
I
Audio serial data input terminal Not used
116
SYNC
I
Synchronous/asychronous selection signal input terminal
“L”: Synchronous, “H”: asynchronous (fixed at “H” in this set)
117 to 119
VSS
—
Ground terminal
120
VDDI
—
94
Description
HCD-C770/C990
• DVD BOARD IC701 CXD1882R (DVD DECODER)
Pin No.
Pin Name
I/O
Description
1, 2
D5, D6
I/O
Two-way data bus with the mechanism controller
3
VSS
—
4
D7
I/O
5
A0
I
6
VDD
—
Address signal input from the mechanism controller
7
A1
I
8
VDD5V
—
9 to 14
A2 to A7
I
15
VSS
—
16
XWAIT
O
Wait signal output terminal
17
XRD
I
Read strobe signal input from the mechanism controller
18
XWR
I
Write strobe signal input from the mechanism controller
Power supply terminal (+5V)
Not used
19
XCS
I
Chip select signal input from the mechanism controller
20, 21
XINT0, XINT1
O
Interrupt signal output to the mechanism controller
22
VDD
—
23
XHRS
I
Not used
24
HDB7
O
Stream data signal output to the DSD decoder and DVD system processor
25
VSS
—
26
HDB8
O
Error flag signal output to the DSD decoder and DVD system processor
27
HDB6
O
28
VDDS
—
Power supply terminal (+5V) (digital system)
29
HDB9
O
Not used
30
HDB5
O
31
HDBA
O
Not used
32
HDB4
O
33
VSS
—
34
HDBB
O
Not used
35
HDB3
O
36
VDD
—
37
HDBC
O
Not used
38
VDDS
—
39
HDB2
O
40
HDBD
O
Not used
41
HDB1
O
42
VSS
—
43
HDBE
O
Not used
44
HDB0
O
45
HDBF
O
Not used
46
XSAK
O
Serial data effect flag signal output to the DSD decoder and DVD system processor
47
VDDS
—
48
XDCK
O
Serial data transfer clock signal output to the DSD decoder and DVD system processor
49
XSHD
O
Header flag signal output to the DSD decoder
50
VDD
—
51
REDY
O
Not used
52
VSS
—
95
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
53
XSRQ
I
DVD mode: Serial data request signal input from the DVD system processor
SACD mode: Serial data request signal input from the DSD decoder
54
HINT
O
Not used
55
XS16
O
Not used
56
HA1
I
Not used
57
XPDI
I/O
Not used
58
VDDS
—
59, 60
HA0, HA2
I
61
VSS
—
62, 63
HCS0, HCS1
I
64
VDD
—
65
DASP
66 to 69 MDB0 to MDB3
Not used
Not used
I/O
Not used
I/O
Two-way data bus with the D-RAM
70
VSS
—
71
MDB4
I/O
72
VDD5V
—
I/O
XMWR
O
Write enable signal output to the D-RAM
77
VDD
—
78
XRAS
O
Row address strobe signal output to the D-RAM
79, 80
MA0, MA1
O
Address signal output to the D-RAM
81
VSS
—
82 to 87
MA2 to MA7
O
88
VDD
—
89
MA8
O
90
VSS
—
91
MA9
O
92
MNT1
O
EEPROM ready signal output to the mechanism controller
93
MNT2
O
Operation clock signal output for PSP physical disc mark detection to DSD decoder
94
XMOE
O
Output enable signal output to the D-RAM
95
XCAS
O
Column address strobe signal output to the D-RAM
96, 97
MDB8, MDB9
I/O
73 to 75 MDB5 to MDB7
76
98
VSS
—
99
MDBA
I/O
100
VDD
—
101, 102
MDBB, MDBC
I/O
103
VDD5V
104 to 106 MDBD to MDBF
—
I/O
107
GFS
O
Guard frame sync signal output to the mechanism controller
108
VSS
—
109
APEO
O
Absolute phase error signal output
110
VDD
—
111
DASYO
O
RF binary signal output
112
GNDA5
—
113, 114
ASF1, AFS2
—
Filter connected terminal for selection the constant asymmetry compensation
115
DASYI
I
96
Analog signal input after integrated from the RF binary signal
HCD-C770/C990
Pin No.
Pin Name
I/O
116
RFDCC
I
Input terminal for adjusting DC cut high-pass filter for RF signal Not used
117
RFIN
I
RF signal input from the DVD/CD RF amplifier
118, 119 VCCA5, VCCA4
Description
—
120
VCOR1
—
VCO oscillating range setting resistor connected terminal
121
VCOIN
I
122, 123 GNDA4, GNDA3
VCO input terminal
—
124
LPF5
O
Signal output from the operation amplifier from PLL loop filter
125
VC1
I
126, 127
LPF2, LPF1
I
Inverted signal input to the operation amplifier from PLL loop filter
128, 129 VCCA3, VCCA2
—
130
PDO
O
Signal output from the charge pump for phase comparator
131
PDHVCC
I
Middle point voltage input terminal for RF PLL
132
FDO
O
Signal output from the charge pump for frequency comparator
133, 134 GNDA2, GNDA1
—
135
SPO
O
Spindle motor control signal output
136
VC2
I
137
MDIN2
I
Spindle motor servo drive signal input
138
MDIN1
I
MDP input terminal
139
VCCA1
—
140
CLVS
O
Control signal output for selection the spindle control filter constant at CLVS
141
VSS
—
142
MDSOUT
O
Frequency error output terminal of internal CLV circuit
143
VDD
—
144
MDPOUT
O
Phase error output terminal of internal CLV circuit
145
DEFECT
I
Defect signal input terminal Not used
146
GSCOR
I
Guard subcode sync (S0+S1) detection signal input from the digital signal processor
147
EXCK
O
Subcode serial data reading clock signal output to the digital signal processor
148
SBIN
I
Subcode serial data input from the digital signal processor
149
VSS
—
150
SCOR
I
Subcode sync (S0+S1) detection signal input from the digital signal processor
151
WFCK
I
Write frame clock signal input from the digital signal processor
152
VDD5V
—
153
XRCI
I
154
VDDS
—
155
C2PO
I
156
VDD
—
157
DBCK
O
Bit clock signal (2.8224 MHz) output terminal Not used
158
BCLK
I
Bit clock signal (2.8224 MHz) input from the digital signal processor
159
DDAT
O
PCM data output terminal Not used
160
MDAT
I
Serial data input from the digital signal processor
161
VSS
—
162
DLRC
O
L/R sampling clock signal (44.1 kHz) output terminal Not used
163
LRCK
I
L/R sampling clock signal (44.1 kHz) input from the digital signal processor
164
XRST
I
Reset signal input from the mechanism controller “L”: reset
165
IFS0
I
Interface selection signal input terminal Fixed at “L” in this set
166
IFS1
I
Interface selection signal input terminal Fixed at “H” in this set
RAM overflow signal input terminal Not used
C2 pointer signal input from the digital signal processor
97
HCD-C770/C990
Pin No.
Pin Name
I/O
167
XTAL
I
168
VSS
—
169
XTA2
O
System clock output terminal (33.8688 MHz)
170
XTA1
I
System clock input terminal (33.8688 MHz)
171
VDD
—
172 to 176
D0 to D4
I/O
98
Description
33.8688 MHz clock signal input terminal
HCD-C770/C990
• DVD BOARD IC801 CXD2752R (DSD DECODER)
Pin No.
Pin Name
I/O
1
VSCA0
—
Description
Ground terminal (for core)
2
XMSLAT
I
Serial data latch pulse signal input from the mechanism controller
3
MSCK
I
Serial data transfer clock signal input from the mechanism controller
4
MSDATI
I
Serial data input from the mechanism controller
5
VDCA0
—
Power supply terminal (+2.5V) (for core)
6
MSDATO
O
Serial data output to the mechanism controller
7
MSREADY
O
Ready signal output to the mechanism controller
8
XMSDOE
O
Serial data output enable signal output terminal
“L”: ready
Not used
9
XRST
I
Reset signal input from the mechanism controller
10
SMUTE
I
Soft muting on/off control signal input from the mechanism controller
11
MCKI
I
Master clock signal (33.8688 MHz) input
12
VSIOA0
—
Ground terminal (for I/O)
13
EXCKO1
O
Master clock signal (33.8688 MHz) output to the digital audio processor
14
EXCKO2
O
External clock 2 signal output terminal
15
LRCK
O
L/R sampling clock signal (44.1kHz) output terminal
16
F75HZ
O
Not used
17
VDIOA0
—
Power supply terminal (+3.3V) (for I/O)
O
Monitor signal output terminal
I
Clock signal input from the DVD system processor
Serial data input from the DVD system processor
18 to 25 MNT0 to MNT7
26
TCK
“H”: muting on
Not used
Not used
Not used
27
TDI
I
28
VSCA1
—
29
TDO
O
Serial data output to the DVD system processor
30
TMS
I
MS signal input from the DVD system processor
31
TRST
I
Reset signal input from the DVD system processor
I
Input terminal for the test (normally: fixed at “L”)
32 to 34 TEST1 to TEST3
“L”: reset
35
VDCA1
—
36
UBIT
O
Not used
37
XBIT
O
Not used
38 to 41
SUPDT0 to
SUPDT3
O
Supplementary data output terminal
42
VSIOA1
—
43, 44
SUPDT4, SUPDT5
O
45
VDIOA1
—
46, 47
SUPDT6, SUPDT7
O
48
SUPEN
O
Supplementary data enable signal output terminal
49
VSCA2
—
50
NC
O
Not used
51, 52
TEST4, TEST5
I
53
NC
O
Not used
“L”: reset
Not used
Not used
Not used
Not used
54
VDCA2
—
55, 56
NC
O
Not used
57
BCKASL
I
Input/output selection signal input terminal of bit clock signal (2.8224 MHz) for DSD data output
“L”: input (slave), “H”: output (master) Fixed at “H” in this set
58
VSDSD0
—
Ground terminal (for DSD data output)
59
BCKAI
I
Bit clock signal (2.8224 MHz) input terminal for DSD data output
60
BCKAO
O
Bit clock signal (2.8224 MHz) output terminal for DSD data output
Not used
Not used
99
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
61
PHREFI
I
Bit clock signal (2.8224 MHz) input terminal for DSD data output
62
PHREFO
O
Bit clock signal (2.8224 MHz) output to the digital audio processor
63
ZDFL
O
Front L-ch Zero data flag detection signal output terminal
64
DSAL
O
Front L-ch DSD data output to the digital audio processor
65
ZDFR
O
Front R-ch Zero data flag detection signal output terminal
66
DSAR
O
Front R-ch DSD data output to the digital audio processor
67
VDDSD0
—
Power supply terminal (+3.3V) (for DSD data output)
68
ZDFC
O
Center zero data flag detection signal output terminal
69
DSAC
O
Center DSD data output to the digital audio processor
70
ZDFLFE
O
Woofer zero data flag detection signal output terminal
71
DSALFE
O
Woofer DSD data output to the digital audio processor
72
VSDSD1
—
Ground terminal (for DSD data output)
73
ZDFLS
O
Rear L-ch zero data flag detection signal output terminal
74
DSALS
O
Rear L-ch DSD data output to the digital audio processor
75
ZDFRS
O
Rear R-ch zero data flag detection signal output terminal
76
DSARS
O
Rear R-ch DSD data output to the digital audio processor
77
VDDSD
—
Power supply terminal (+3.3V) (For DSD data output)
78, 79
IOUT0, IOUT1
O
Data output terminal for IEEE 1394 link chip interface
80
VSCB0
—
81, 82
IOUT2, IOUT3
O
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
83
VDCB0
—
84, 85
IOUT4, IOUT5
O
86
VSIOB0
—
87
IANCO
O
Transmission information data output terminal for IEEE 1394 link chip interface
88
IFULL
I
Data transmission hold request signal input terminal for IEEE 1394 link chip interface
High speed transmission request signal input terminal for IEEE 1394 link chip interface
Not used
Not used
89
IEMPTY
I
90
VDIOB0
—
91
IFRM
O
Frame reference signal output terminal for IEEE 1394 link chip interface
92
IOUTE
O
Enable signal output terminal for IEEE 1394 link chip interface
93
IBCK
O
Data transmission clock signal output terminal for IEEE 1394 link chip interface
94
VSCB1
—
95
IERR
I
Not used
96
IANCI
I
Not used
97
IPLAN
I
Not used
98
IHOLD
O
Not used
99
VDCB1
—
100
IVLD
I
Not used
I
Not used
101 to 105 IDIN0 to IDIN4
106
VSIOB1
107 to 109 IDIN5 to IDIN7
110
VDIOB1
111 to 114 WAD0 to WAD3
—
I
—
I
—
117 to 120 WAD4 to WAD7
121
100
VDCB2
Not used
TESTI
VSCB2
I
—
Not used
External A/D data input terminal for PSP physical disc mark detection
116
Not used
External A/D data input terminal for PSP physical disc mark detection
Not used
Not used
I
115
Not used
Not used
Not used
HCD-C770/C990
Pin No.
Pin Name
I/O
122
WRFD
I
Not used
123
WCK
I
Operation clock signal input for PSP physical disc mark detection from the DVD decoder
124, 125
WAVDD0,
WAVDD1
—
126
WARFI
I
Analog RF signal input for PSP physical disc mark detection from the DVD/CD RF amplifier
127
WAVRB
I
A/D bottom reference terminal for PSP physical disc mark detection
128, 129 WAVSS0, WAVSS1
Description
A/D power supply terminal (+2.5V) (for PSP physical disc mark detection)
—
A/D ground terminal (for PSP physical disc mark detection)
130
VSIO
—
131 to 134
DQ7 to DQ4
I/O
Two-way data bus with the SD-RAM
135
VDIOA2
—
136 to 139
DQ3 to DQ0
I/O
Two-way data bus with the SD-RAM
140
VSIOA3
—
141
DCLK
O
Clock signal output to the SD-RAM
142
DCKE
O
Clock enable signal output to the SD-RAM
143
XWE
O
Write enable signal output to the SD-RAM
144
XCAS
O
Column address strobe signal output to the SD-RAM
145
XRAS
O
Row address strobe signal output to the SD-RAM
146
VDIOA3
—
147
NC
O
Not used
148, 149
A11, A10
O
Address signal output to the SD-RAM
150
VSCA3
—
151, 152
A9, A8
O
153
VDCA3
—
154 to 157
A7 to A4
O
158
VSIOA4
—
159 to 162
A3 to A0
O
163
VDIOA4
—
164
XSRQ
O
Serial data request signal output to the DVD decoder
165
XSHD
I
Header flag signal input from the DVD decoder
166
SDCK
I
Serial data transfer clock signal input from the DVD decoder
167
XSAK
I
Serial data effect flag signal input from the DVD decoder
168
SDEF
I
Error flag signal input from the DVD decoder
169 to 176
SD0 to SD7
I
Stream data signal input from the DVD decoder
101
HCD-C770/C990
• DVD BOARD IC901 µPD703033BYGF-M01-3BA (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
1
DAMP-DATA
O
Description
Serial data output to the stream processors
2
DAMP-CLK
O
Serial data transfer clock signal output to the stream processors
3
I2C-DATA
I/O
Communication data bus with the DVD system processor and mechanism controller
4
CQ-RST
O
Reset signal output to the DVD system processor
5
I2C-CLK
I/O
Communication data reading clock signal input or transfer clock signal output with the DVD
system processor and mechanism controller
6
DSP-DO
I
Write data input from the audio digital signal processor
7
DIG-DI
O
Read data output to the digital audio interface IC, audio digital signal processor and D/A
converter
8
DIG-CLK
O
Clock signal output to the digital audio interface IC, audio digital signal processor and D/A
converter
9
EVDD
—
10
EVSS
—
Ground terminal
11
P-PWM
O
PWM voltage control signal output
12
DSP-RST
O
Reset signal output to the audio digital signal processor
13
DSP-PM
O
PLL reset signal output to the audio digital signal processor
14
DSP-CS
O
Chip select signal output to the audio digital signal processor
15
DSP-HACN
I
Acknowledge signal input from to the audio digital signal processor
16
DSP-BST
O
Boot trap signal output to the audio digital signal processor
17
DSP-GP9
I
Decode signal input from to the audio digital signal processor
18
DIR-ZERO
I
Audio serial data input from the digital audio interface IC
19
DIR-ERR
I
PLL lock error and data error flag input from the digital audio interface IC
“L”: reset
“L”: reset
“L”: reset
20
DIR-CE
O
Chip enable signal output to the digital audio interface IC
21
VPP
—
Power supply terminal (for programming)
22
DIR-XST
I
Source clock switching monitor input from the digital audio interface IC
23
DIR-AD
O
Not used
24
DIR-XMODE
I
System reset signal input from the digital audio interface IC
25
DI
I
Write data input from the digital audio interface IC
26
DAMP-RST
O
Reset signal output to the stream processors
27
DAMP-MUTEG
O
Muting on/off control signal output to the stream processors
“H”: muting on
28
DAMP-MUTEN
O
Muting on/off control signal output to the stream processors
“H”: muting on
29
CS1
O
Chip select signal output to the stream processor (for front L-ch and R-ch)
30
CS2
O
Chip select signal output to the stream processor (for center and woofer)
Not used
“L”: reset
“L”: reset
31
CS3
O
Chip select signal output to the stream processor (for rear L-ch and R-ch)
32
DAC-CS
O
Chip select signal output to the D/A converter
33
AD-RST
O
Reset signal output to the A/D converter and D/A converter
34
RESET
I
System reset signal input “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
35
XT1
I
Sub system clock input terminal
36
XT2
O
Sub system clock output terminal
37
REG0
—
Not used
38
X2
O
Main system clock output terminal (20 MHz)
Main system clock input terminal (20 MHz)
39
X1
I
40
VSS
—
Ground terminal
41
VDD
—
42
CLKOUT
O
Clock signal output terminal
102
Not used
Not used
Not used
“L”: reset
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
43
DIP-RST
O
Reset signal output to the power amplifier
44
DIP-OCP
I
Protect signal input from the power amplifier
45
ST-POWER
O
System power on/off control signal output
46
HP-MUTE
O
Headphone muting on/off control signal output
47
AU-MUTE
O
Audio line muting on/off control signal output
48
AV-SEL2
O
Audio/video selection signal output
49
PROG SW
I
SCAN SELECT switch input terminal
50
TU-ON
O
Power supply for tuner pack on/off control signal output
“L”: reset
“H”: power on
“L”: muting on
“L”: muting on
“L”: SELECTABLE, “H”: INTERLACE
51
TUNED
I
Tuning detection signal input from the tuner unit
52
TUN-DI
I
Serial data input from the tuner unit
53
TUN-CE
O
Chip enable signal output to the tuner unit
54
TUN-DO
O
Serial data output to the tuner unit
55
TUN-CLK
O
Serial data transfer clock signal output to the tuner unit
56
FL-MUTE
O
Reset signal output to the fluorescent indicator tube driver
57
FL-CLK
O
Serial data transfer clock signal output to the LED driver and fluorescent indicator tube driver
58
BVDD
—
Power supply terminal (+5V) (for bus interface)
59
BVSS
—
Ground terminal (for bus interface)
60
FL-DATA
O
Serial data output to the LED driver and fluorescent indicator tube driver
“L”: tuned
“L”: reset
61
FL-CS
O
Chip select signal output to the fluorescent indicator tube driver
62
LED-CS
O
Standby signal output to the LED driver
63
LED-CLR
O
Reset signal output to the LED driver
64
HPSW
I
Connection detection signal input of the headphone jack
“L”: no connected, “H”: headphone connected
65
DFIL RST2
O
Reset signal output to the digital audio processor
66
SP RELAY
O
Relay drive signal output terminal for the speaker protect
67
PARA-DO2
I
Serial data input from the changer controller (rotary encoder)
68
PARA-RST
O
Reset signal output to the changer controller (motor, switch) and changer controller (rotary
encoder) “L”: reset
69
PARA-LT1
O
Serial data latch pulse signal output to the changer controller (motor, switch)
“L” active
“L”: standby
“L”: reset
“L”: reset
Not used
70
PARA-LT2
O
Serial data latch pulse signal output terminal
71
PARA-CLK
O
Serial data transfer clock signal output to the changer controller (motor, switch)
72
PARA-DATA
O
Serial data output to the changer controller (motor, switch)
73
PARA-DO1
I
Serial data input terminal
74
AVDD
—
Power supply terminal (+5V) (analog system)
75
AVSS
—
76
AVREF
I
77
NO USE
—
Not used
78
OPT-SEN2
I
Not used
79
OPT-SEN
I
Disc insert detection signal input from the disc sensor
80
AREA1
I
Destination setting terminal
81
SEN2
I
Disc loading detection signal input
82 to 84
KEY0 to KEY2
I
Key input terminal (A/D input)
85
EN-A
I
Jog dial pulse input from the rotary encoder (A phase input)
86
EN-B
I
Jog dial pulse input from the rotary encoder (B phase input)
87
MODEL
I
Model setting terminal
88
RDS-DATA
I
RDS serial data input from the RDS decoder (Used for the AEP model)
89
DVD-POWER
O
DVD power on/off control signal output
90
STOP
I
System stop signal input
Not used
Not used
Reference voltage (+5V) input terminal (analog system)
“H”: power on
103
HCD-C770/C990
Pin No.
Pin Name
I/O
Description
91
POWER-SW
I
System power on/off control signal input “H”: power on
92
SIRCS
I
Remote control signal input
93
WAKE
I
System wake up signal input by pressing any key on the front panel or remote commander or disc
insert detect sensor
94
RDS-CLK
I
RDS serial data transfer clock signal input from the RDS decoder (Used for the AEP model)
95
AV-SEL0
O
96
AV-SEL1
O
97
DF-SW
O
selection signal output to the digital audio processor
98
DF-SYNC
O
Sync signal output to the digital audio processor
99
DF-RST
O
Reset signal output for the digital audio processor
100
I2HLP
I/O
Busy signal input/output for the I2C bus
104
“L”: reset Not used
HCD-C770/C990
• DVD BOARD IC902 PT3000 (CHANGER CONTROLLER (MOTOR, SWITCH) )
Pin No.
Pin Name
I/O
Description
1
VSS
—
2
RESET
I
3
CLK
I
Serial data transfer clock signal input from the system controller
4
LAT
I
Serial data latch pulse signal input from the system controller
5
P15
I
Disc insert (8/12cm) detect switch input terminal “L”: disc insert
6
P14
I
Disc insert (12cm) detect switch input terminal “L”: disc insert Not used
7
P13
I
Disc in (8/12cm) detect switch input terminal “L”: play position
8
P12
I
Disc in (12cm) detect switch input terminal “L”: play position
9
P11
I
Stocker in/out detect switch input terminal “L”: in the midst disc is moving between play
position and stocker except the moment disc in/out from stocker
10
P10
I
Disc position detect switch input terminal
“L”: disc is play position side in the midst disc is moving between play position and stocker,
“H”: disc is stocker side in the midst disc is moving between play position and stocker
11
P9
I
Disc out detect switch input terminal “H”: disc out from play position
12
P8
I
Stocking detect switch input terminal
“H”: in the midst disc is moving between play position and stocker
13
LATCHO
O
Serial data latch pulse signal output to the changer controller (rotary encoder)
14
CLKO
O
Serial data transfer clock signal output to the changer controller (rotary encoder)
15
DO1
O
Serial data output to the changer controller (rotary encoder)
16
DI2
I
Serial data input terminal Not used
17, 18
P7, P6
O
Not used
19, 20
P5, P4
O
Elevator up/down motor drive control signal output
21, 22
P3, P2
O
Rollar motor drive control signal output
23, 24
P1, P0
O
Loading motor drive control signal output
25
DO2
O
Serial data output to the changer controller (rotary encoder)
26
DI1
I
Serial data input from the system controller
27
PULLUP
—
Connected to power supply (+5V)
28
VCC
—
Ground terminal
“L”: reset
105
HCD-C770/C990
• DVD BOARD IC906 PT3000 (CHANGER CONTROLLER (ROTARY ENCODER) )
Pin No.
Pin Name
I/O
Description
1
VSS
—
2
RESET
I
3
CLK
I
Serial data transfer clock signal input from the changer controller (motor, switch)
4
LAT
I
Serial data latch pulse signal input from the changer controller (motor, switch)
5 to 8
P15 to P12
I
Stocker position detect rotary encoder input terminal
Ground terminal
“L”: reset
9 to 12
P11 to P8
I
Mode detect rotary encoder input terminal
13
LATCHO
O
Serial data latch pulse signal output terminal Not used
14
CLKO
O
Serial data transfer clock signal output terminal Not used
15
DO1
O
Serial data output terminal Not used
16
DI2
I
Serial data input from the changer controller (motor, switch)
17 to 24
P7 to P0
O
Not used
25
DO2
O
Serial data output to the system controller
Serial data input from the changer controller (motor, switch)
26
DI1
I
27
PULLUP
—
Connected to power supply (+5V)
28
VCC
—
106
HCD-C770/C990
SECTION 8
EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet's Color
8-1.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• Abbreviation
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiquens pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
GENERAL SECTION
front panel section-1
#1
#1
mechanism deck
section-1
(CDM69-DVBU16)
#1
1
#1
#1
chassis section-1
#1
2
Ref. No.
1
2
Part No.
Description
4-240-373-01 SIDE PANEL (L)
4-240-374-01 SIDE PANEL (R)
Remark
Ref. No.
#1
Part No.
Description
Remark
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
107
HCD-C770/C990
8-2.
FRONT PANEL SECTION-1
front panel section-2
#1
54
not
supplied
55
#1
#1
53
56
57
51
52
not supplied
58
supplied with S800
Ref. No.
51
52
53
54
55
108
Part No.
Description
4-240-382-01
4-240-383-01
1-685-068-11
A-4676-963-A
1-685-084-11
CD BUTTON
BAND BUTTON
CONTROL BOARD
DDCON BOARD, COMPLETE
VOL BOARD
Remark
Ref. No.
56
57
58
58
#1
Part No.
Description
2-626-294-01
1-685-083-11
4-240-024-01
X-4952-564-1
7-685-646-79
SCREW (+ PTPWH) (2.6X7)
HP BOARD
KNOB VOLUME (C770)
KNOB (VOL) ASSY (C990)
SCREW +BVTP 3X8 TYPE2 IT-3
Remark
HCD-C770/C990
8-3.
FRONT PANEL SECTION-2
107
#1
#7
#1
not
supplied
(power LED board)
106
#1
108
109
103
#1
FL801
111
105
110
104
101
102
Ref. No.
Part No.
Description
101
102
103
104
105
X-4954-740-3
X-4954-729-2
4-240-402-01
1-824-479-11
1-685-082-11
WINDOW SUB ASSY
LID SUB ASSY, CD
FL HOLDER
FLEXIBLE FLAT CABLE (10 CORE)
FL BOARD
106
107
107
X-4954-736-1 POWER SUB ASSY
4-240-372-01 FRONT PANEL (AL) (C770)
4-241-536-01 PANEL (AL), FRONT (C990)
Remark
Ref. No.
Part No.
Description
108
109
110
111
FL801
X-4954-734-1
A-4728-876-A
1-824-478-11
4-931-757-31
1-518-824-11
PLAY BUTTON SUB ASSY
KEY BOARD, COMPLETE
SCREW (DIA.2.6X8) (IT3B), TAPPING
INDICATOR TUBE, FLUORESCENT
#1
#7
7-685-246-14 SCREW +KTP 3X8 TYPE2 NON-SLIT
Remark
109
HCD-C770/C990
8-4.
CHASSIS SECTION-1
#1
not supplied
not supplied
(SEL board)
#2
#1
152
not supplied
not supplied
(power SW board)
#1
chassis section-2
151
153
#1
Ref. No.
151
152
153
110
Part No.
Description
X-4954-745-1 FOOT SUB ASSY
4-240-397-01 POWER BUTTON
4-240-410-01 FOOT
Remark
Ref. No.
#1
#2
Part No.
Description
7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S
Remark
HCD-C770/C990
8-5.
CHASSIS SECTION-2
F901
#1
#1
#1
#1
#1
not
supplied
211
210
202
not
supplied
205
204
203
not
supplied
#1
201
207
208
#1
212
206
209
chassis section-3
mark 0 or dotted line with
mark 0 are critical for safety.
Ref. No.
Part No.
Description
201
202
203
203
203
1-824-626-11
1-824-483-11
A-4676-951-A
A-4729-049-A
A-4730-636-A
DVD BOARD, COMPLETE (C770: US, CND)
DVD BOARD, COMPLETE (C990)
DVD BOARD, COMPLETE (C770: AEP)
Remark
203
204
205
206
207
A-4730-646-A
1-824-478-11
1-824-625-11
1-500-657-11
1-824-480-11
DVD BOARD, COMPLETE (C770: AUS)
CORE, FERRITE
208
1-824-481-11 FLEXIBLE FLAT CABLE (14 CORE)
Ref. No.
209
210
210
210
211
211
212
0 F901
0 F901
#1
marque 0 sont critiques pour la
sécurité.
Part No.
Description
1-824-482-11
A-4676-957-A
A-4729-053-A
A-4730-639-A
A-4676-968-A
POWER BOARD, COMPLETE (C770: US, CND)
POWER BOARD, COMPLETE (C990)
POWER BOARD, COMPLETE (AEP, AUS)
AMP BOARD, COMPLETE (US, CND)
Remark
A-4730-644-A AMP BOARD, COMPLETE (AEP, AUS)
1-469-854-11 CORE, FERRITE
1-533-453-11 FUSE, GLASS TUBE (DIA. 5) (5A/125V)
(US, CND)
(AEP, AUS)
111
HCD-C770/C990
8-6.
CHASSIS SECTION-3
not
supplied
#1
252
#1
#1
256
251
#3
255
#1
not supplied
M301
253
#1
254
258
not
supplied
257
not supplied
Ref. No.
Part No.
Description
251
252
0 253
0 253
0 253
A-4728-874-A
1-824-485-11
1-783-531-72
1-696-169-12
1-696-848-42
VIDEO BOARD, COMPLETE
CORD, POWER (US, CND)
CORD, POWER (AEP)
CORD, POWER (AUS)
254
255
255
256
4-217-350-11
A-4728-875-A
A-4730-641-A
4-931-757-31
STOPPER, CORD
AUDIO BOARD, COMPLETE (EXCEPT AEP)
AUDIO BOARD, COMPLETE (AEP)
SCREW (DIA. 2.6X8) (IT3B), TAPPING
112
Remark
Ref. No.
257
258
Part No.
sécurité.
Description
Remark
M301
#1
A-4730-139-A TUNER BOARD, COMPLETE (DTP-001)
(AEP, AUS)
(US, CND)
1-763-861-11 FAN, DC
#3
7-685-659-14 SCREW +BVTP 4X8 TYPE2 N-S
258
HCD-C770/C990
8-7.
MECHANISM DECK SECTION-1
(CDM69-DVBU16)
305
304
302
#4
S702
303
#4
301
306
M781
308
309
mechanism deck section-2
307
310
302
#4
Ref. No.
Part No.
Description
301
302
303
304
305
1-685-006-11
4-951-620-01
4-239-690-01
4-239-618-01
X-4954-628-1
STOCKER MOTOR BOARD
SCREW (2.6X8), +BVTP
CAM (STOCKER U/D)
SCREW (+PWH, 2X6), STEP TAPPING
STOCKER ASSY
306
307
4-239-687-01 GEAR (STOCKER COMMUNICATION)
A-4728-700-A RELAY BOARD, COMPLETE
Remark
Ref. No.
Part No.
Description
Remark
308
309
310
M781
S702
4-239-689-01
4-239-698-01
4-240-035-01
A-4735-953-A
1-477-299-11
GEAR (STOCKER DECELERATION)
PULLEY (STOCKER)
BELT (STOCKER)
MOTOR (STOCKER) ASSY (STOCKER)
ENCODER, ROTARY (STOCKER POSITION)
#4
7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
113
HCD-C770/C990
8-8.
(CDM69-DVBU16)
352
353
354
355
#5
355
351
356
optical pick-up
(DVBU16)
Ref. No.
351
352
353
354
114
Part No.
Description
1-685-008-11
1-685-009-11
1-685-010-11
1-685-011-11
SW BOARD (1)
SW BOARD (2)
SW BOARD (3)
SW BOARD (4)
Remark
Ref. No.
355
356
#5
Part No.
Description
4-951-620-01 SCREW (2.6X8), +BVTP
4-985-672-01 SCREW (+PTPWHM 2.6), FLOATING
7-685-533-14 SCREW +BTP 2.6X6 TYPE2 N-S
Remark
HCD-C770/C990
8-9.
(CDM69-DVBU16)
407
not supplied
406
not
supplied
not supplied
405
409
410
405
413
not
supplied
411
420
409
408
415
402
413
412
not
supplied
405
414
415
416
not supplied
404
418
403
417
404
419
402
402
418
not supplied
402
401
Ref. No.
Part No.
Description
Part No.
Description
401
402
403
404
405
4-240-038-01
4-992-069-01
4-239-648-01
4-239-646-01
4-239-641-01
PULLEY (A), CHUCKING
SCREW (+PTPWH) (M2) (DIA. 7)
PARASOL (ROLLER)
ROLLER (ROLLER)
SPRING (1.2), TENSION
Remark
411
412
413
414
415
4-239-651-01
4-239-640-01
4-240-040-01
4-240-039-01
4-239-702-01
ROLLER (STOCKER), RUBBER
PINION (SLIDER)
SPRING (DISC STOPPER), TORSION
LEVER (DISC STOPPER)
ROLLER (DISC STOPPER)
406
407
408
409
410
4-239-642-01
4-239-679-01
4-240-037-01
4-239-649-01
4-241-209-01
SPRING (3), TENSION COIL
SPRING (5), TENSION COIL
PULLEY (B), CHUCKING
PARASOL (STOCKER)
SHEET, ADHESIVE
416
417
418
419
420
4-985-672-01
4-239-650-01
4-239-647-01
4-239-645-01
4-241-599-01
SCREW (+PTPWHM 2.6), FLOATING
LEVER (LIFTER)
PARASOL (MAIN)
ROLLER, RUBBER
LEVER (SUPPORT)
Ref. No.
Remark
115
HCD-C770/C990
8-10. MECHANISM DECK SECTION-4
(CDM69-DVBU16)
#6
457
#6
457
458
454
457
454
458
457
453
456
455
455
#6
457
457
452
458
470
#6
467
468
453
456
456
454
451
452
457
463
461
465
457
455
461
452
461
460
464
453
not
supplied
465
457
456
470
455
456
458
469
471
462
#6
#6
451
461
466
466
472
454
455
453
452
not supplied
(roller motor board)
451
M771
mechanism deck
section-5
Ref. No.
Part No.
Description
Part No.
Description
451
452
453
454
455
X-4954-626-1
4-239-666-01
4-239-668-01
4-239-652-01
4-239-669-01
LEVER (ROLLER) ASSY
GEAR
LEVER (CENTER)
SCREW (ROLLER), STEP
GEAR (ROLLER COMMUNICATION)
464
465
466
467
468
4-240-981-01
4-240-041-01
4-951-620-01
4-241-467-01
4-239-651-01
SPRING (BASE SLIDER 5),TENSION
SPRING (SLIDER 2), TENSION
ROLLER (S), RUBBER
ROLLER (STOCKER) RUBBER
456
457
458
460
461
4-239-667-01
4-239-647-01
4-239-645-01
X-4954-622-1
4-239-670-01
GEAR (ROLLER CENTER)
PARASOL (MAIN)
ROLLER, RUBBER
BASE (SLIDER 2) ASSY
GEAR (ROLLER 5 COMMUNICATION)
469
470
471
472
M771
4-241-209-01
4-239-649-01
4-239-671-01
X-4954-627-1
A-4735-953-A
SHEET, ADHESIVE
PARASOL (STOCKER)
GEAR (ROLLER 5 CENTER)
BASE (SLIDER 5) ASSY
MOTOR (STOCKER) ASSY (ROLLER)
462
463
X-4954-624-A LEVER (SLIDER 4) ASSY
4-992-069-01 SCREW (+PTPWH) (M2) (DIA. 7)
#6
7-623-921-01 WASHER 1.7, NYRON
116
Remark
Ref. No.
Remark
HCD-C770/C990
(CDM69-DVBU16)
504
503
505
503
505
501
502
506
509
mechanism deck
section-6
507
508
#4
Ref. No.
501
502
503
504
505
Part No.
Description
4-240-020-01
4-239-708-01
4-239-697-01
X-4954-629-1
4-239-706-01
GEAR (TIMING)
BELT (FRONT), TIMING
GEAR (CENTER)
SLIDER (MODE CAM) ASSY
BELT (REAR), TIMING
Remark
Ref. No.
506
507
508
509
#4
Part No.
Description
4-239-699-01
4-239-681-01
4-227-899-01
4-239-686-01
7-685-902-21
PULLEY
BELT (ROLLER)
SCREW (DIA. 12), FROATING
GEAR (ROLLER DECELERATION)
SCREW +PTPWH 2.6X8 (TYPE2)
Remark
117
HCD-C770/C990
(CDM69-DVBU16)
563
not supplied
(mode motor board)
not supplied
565
M761
551
#4
#4
554
555
#4
#4
556
#4
553
558
564
569
560
570
568
557
#4
559
562
563
#4
552
#4
#4
S771
567
563
563
561
571
566
#4
Ref. No.
Part No.
Description
Part No.
Description
551
552
553
554
555
4-239-693-01
1-685-004-11
4-239-696-01
4-239-695-02
4-240-018-01
CAM (GEAR)
SENSOR BOARD
GEAR (EJECT LOCK)
CAM (EJECT LOCK)
GEAR (MODE 4)
563
564
565
566
567
4-951-620-01
4-239-692-01
4-239-694-01
4-241-731-01
4-241-732-01
CAM (BU U/D)
GEAR (MODE CAM)
SHUTTER (A), LEVER
SHUTTER (B), LEVER
556
557
558
559
560
4-240-019-01
4-239-700-01
4-239-683-01
4-239-682-01
4-239-688-01
GEAR (MODE 5)
GEAR (MODE 2)
PULLEY (MODE DECELERATION)
BELT (MODE)
GEAR (MODE 3)
568
569
570
571
M761
4-241-733-01
4-241-734-01
4-241-735-01
4-227-899-01
A-4735-953-A
BASE (SHUTTER)
SHAFT (SHUTTER)
SPRING (SHUTTER), COMPRESSION
SCREW (DIA.12), FLOATING
MOTOR (STOCKER) ASSY (MODE)
561
562
4-239-618-01 SCREW (+PWH, 2X6), STEP TAPPING
4-239-684-01 GEAR (MODE 1)
S771
#4
1-477-300-11 ENCODER, ROTARY (MODE)
7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
118
Remark
Ref. No.
Remark
HCD-C770/C990
8-13. OPTICAL PICK-UP SECTION
(DVBU16)
601
601
603
602
602
601
605
#5
602
604
606
Ref. No.
Part No.
Description
601
602
0 603
604
4-981-923-01
3-053-847-31
1-477-263-11
A-4728-690-A
SCREW (M), STEP
INSULATOR
PICKUP UNIT (TDP022W)
RF BOARD, COMPLETE
Remark
Ref. No.
605
606
#5
Part No.
sécurité.
Description
Remark
1-685-250-11 FLEXIBLE BOARD
4-239-703-01 HOLDER (DBU1)
7-685-533-14 SCREW +BTP 2.6X6 TYPE2 N-S
119
HCD-C770/C990
SECTION 9
ELECTRICAL PARTS LIST
AMP
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Abbreviation
Ref. No.
Part No.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
Description
Remark
Part No.
marque 0 sont critiquens pour la
sécurité.
When indicating parts by reference
number, please include the board.
Description
Remark
A-4676-968-A AMP BOARD, COMPLETE (US, CND)
A-4730-644-A AMP BOARD, COMPLETE (AEP, AUS)
********************
C162
C163
C164
1-115-339-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
10%
10%
10%
50V
50V
50V
C165
C166
C167
C168
C169
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C170
C171
C172
C181
C182
1-115-339-11
1-115-339-11
1-115-339-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C190
C191
C192
C300
C301
1-164-505-11
1-126-193-21
1-216-295-00
1-115-819-11
1-126-153-11
CERAMIC CHIP 2.2uF
ELECT
1uF
CONDUCTOR, CHIP
ELECT
2200uF
ELECT
22uF
20%
16V
50V
20%
20%
35V
6.3V
C302
C303
C304
C306
C307
1-162-970-11
1-136-157-00
1-136-157-00
1-162-970-11
1-162-910-11
CERAMIC CHIP
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.022uF
0.022uF
0.01uF
5PF
10%
5%
5%
10%
0.25PF
25V
50V
50V
25V
50V
C308
C309
C310
C311
C312
1-162-964-11
1-164-156-11
1-162-970-11
1-162-970-11
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001uF
0.1uF
0.01uF
0.01uF
100uF
10%
10%
10%
20%
50V
25V
25V
25V
10V
C313
C316
C317
C318
C319
1-136-165-00
1-163-021-11
1-126-948-11
1-104-665-11
1-107-826-11
FILM
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.1uF
0.01uF
100uF
100uF
0.1uF
5%
10%
20%
20%
10%
50V
50V
35V
10V
16V
C320
C323
C324
C325
C326
1-124-584-00
1-162-970-11
1-162-970-11
1-124-584-00
1-124-589-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100uF
0.01uF
0.01uF
100uF
47uF
20%
10%
10%
20%
20%
10V
25V
25V
10V
16V
C327
C328
C329
C330
C331
1-162-970-11
1-107-826-11
1-126-176-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
220uF
0.01uF
0.1uF
10%
10%
20%
10%
10%
25V
16V
10V
25V
16V
< CAPACITOR/CHIP CONDUCTOR >
C101
C102
C103
C104
C105
1-127-573-11
1-127-573-11
1-127-573-11
1-127-573-11
1-127-573-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C106
C111
C112
C113
C114
1-127-573-11
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
50V
50V
50V
50V
C115
C116
C121
C122
C123
1-163-021-11
1-163-021-11
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C124
C125
C126
C131
C132
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C133
C134
C135
C136
C141
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C142
C143
C144
C145
C146
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C147
C148
C149
C150
C151
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C152
C161
0.01uF
0.1uF
10%
10%
50V
50V
120
Ref. No.
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
HCD-C770/C990
AMP
Ref. No.
Part No.
Description
C332
C333
C334
C336
C337
1-136-165-00
1-136-157-00
1-136-157-00
1-124-584-00
1-107-826-11
FILM
FILM
FILM
ELECT
CERAMIC CHIP
0.1uF
0.022uF
0.022uF
100uF
0.1uF
5%
5%
5%
20%
10%
50V
50V
50V
10V
16V
Remark
C341
C342
C343
C344
C345
1-163-021-11
1-126-948-11
1-107-826-11
1-162-970-11
1-104-665-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
100uF
0.1uF
0.01uF
100uF
10%
20%
10%
10%
20%
50V
35V
16V
25V
10V
C348
C349
C350
C351
C352
1-162-970-11
1-162-970-11
1-124-584-00
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100uF
0.1uF
0.01uF
10%
10%
20%
10%
10%
25V
25V
10V
16V
25V
C353
C354
C355
C356
C358
1-136-165-00
1-136-157-00
1-107-826-11
1-136-157-00
1-162-970-11
FILM
FILM
CERAMIC CHIP
FILM
CERAMIC CHIP
0.1uF
0.022uF
0.1uF
0.022uF
0.01uF
5%
5%
10%
5%
10%
50V
50V
16V
50V
25V
C359
C362
C363
C364
C365
1-162-970-11
1-104-665-11
1-163-021-11
1-126-948-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
100uF
0.01uF
100uF
0.1uF
10%
20%
10%
20%
10%
25V
10V
50V
35V
16V
C368
C372
C373
C374
C375
1-107-826-11
1-107-826-11
1-162-970-11
1-136-165-00
1-136-157-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
0.1uF
0.1uF
0.01uF
0.1uF
0.022uF
10%
10%
10%
5%
5%
16V
16V
25V
50V
50V
C376
C378
C381
C382
C383
1-136-157-00
1-107-826-11
1-104-665-11
1-163-021-11
1-126-948-11
FILM
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.022uF
0.1uF
100uF
0.01uF
100uF
5%
10%
20%
10%
20%
50V
16V
10V
50V
35V
C384
C387
C388
C389
C390
1-107-826-11
1-162-970-11
1-162-970-11
1-124-584-00
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
100uF
0.01uF
10%
10%
10%
20%
10%
16V
25V
25V
10V
25V
C391
C392
C393
C394
C395
1-162-970-11
1-124-584-00
1-162-970-11
1-107-826-11
1-136-165-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
FILM
0.01uF
100uF
0.01uF
0.1uF
0.1uF
10%
20%
10%
10%
5%
25V
10V
25V
16V
50V
C396
C397
C399
C400
C401
1-136-157-00
1-136-157-00
1-107-826-11
1-107-826-11
1-104-665-11
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.022uF
0.022uF
0.1uF
0.1uF
100uF
5%
5%
10%
10%
20%
50V
50V
16V
16V
10V
C402
C403
C404
C405
C406
1-163-021-11
1-126-948-11
1-107-826-11
1-104-665-11
1-107-826-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
100uF
0.1uF
100uF
0.1uF
10%
20%
10%
20%
10%
50V
35V
16V
10V
16V
C407
C408
C409
1-104-665-11 ELECT
100uF
0.1uF
0.01uF
20%
10%
10%
10V
16V
25V
Ref. No.
Part No.
Description
Remark
C410
C411
1-136-165-00 FILM
0.1uF
0.1uF
10%
5%
16V
50V
C412
C413
C414
C415
C416
1-136-157-00
1-136-157-00
1-107-826-11
1-162-970-11
1-162-970-11
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
0.1uF
0.01uF
0.01uF
5%
5%
10%
10%
10%
50V
50V
16V
25V
25V
C417
C418
C419
C420
C421
1-104-665-11
1-107-826-11
1-163-021-11
1-126-948-11
1-107-826-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
0.1uF
0.01uF
100uF
0.1uF
20%
10%
10%
20%
10%
10V
16V
50V
35V
16V
C422
C423
C424
C425
C426
1-104-665-11
1-104-665-11
1-107-826-11
1-104-665-11
1-107-826-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
100uF
0.1uF
100uF
0.1uF
20%
20%
10%
20%
10%
10V
10V
16V
10V
16V
C427
C432
C451
C452
C453
1-104-665-11
1-162-915-11
1-131-704-11
1-131-704-11
1-131-704-11
ELECT
CERAMIC CHIP
FILM
FILM
FILM
100uF
10PF
1uF
1uF
1uF
20%
0.5PF
5%
5%
5%
10V
50V
50V
50V
50V
C454
C455
C456
C457
C458
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
FILM
FILM
FILM
FILM
FILM
1uF
1uF
1uF
1uF
1uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C459
C460
C461
C462
C471
1-131-704-11
1-131-704-11
1-131-704-11
1-131-704-11
1-162-928-11
FILM
FILM
FILM
FILM
CERAMIC CHIP
1uF
1uF
1uF
1uF
120PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C472
C473
C474
C481
C482
1-162-927-11
1-162-927-11
1-126-935-11
1-162-928-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
470uF
120PF
100PF
5%
5%
20%
5%
5%
50V
50V
16V
50V
50V
C483
C484
C490
C491
C493
1-162-927-11
1-126-935-11
1-126-933-11
1-164-156-11
1-126-947-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
100PF
470uF
100uF
0.1uF
47uF
5%
20%
20%
50V
16V
16V
25V
35V
20%
< CONNECTOR >
CN300
CN301
* CN302
CN305
* CN309
1-565-731-11
1-779-280-11
1-564-704-11
1-779-285-11
1-506-987-11
PLUG, CONNECTOR (2.5mm) 5P
CONNECTOR, FFC (LIF (NON-ZIF)) 12P
PIN, CONNECTOR (SMALL TYPE) 2P
CONNECTOR, FFC/FPC (ZIF) 17P
PIN, CONNECTOR (PC BOARD) 5P
< DIODE >
D101
D102
D103
D104
D105
8-719-404-50
8-719-404-50
8-719-404-50
8-719-404-50
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA111-TX
MA111-TX
MA111-TX
MA111-TX
D106
D180
8-719-404-50 DIODE MA111-TX
8-719-975-41 DIODE RB411D-T146
121
HCD-C770/C990
AMP
Ref. No.
Part No.
Description
D181
D190
D191
8-719-404-50 DIODE MA111-TX
8-719-975-41 DIODE RB411D-T146
8-719-975-41 DIODE RB411D-T146
D192
D311
D312
D313
D314
8-719-083-63
6-500-131-01
6-500-131-01
6-500-131-01
6-500-131-01
DIODE
DIODE
DIODE
DIODE
DIODE
UDZSTE-1713B
LI116
LI116
LI116
LI116
D315
D316
D321
D322
D323
6-500-131-01
6-500-131-01
6-500-131-01
6-500-131-01
6-500-131-01
DIODE
DIODE
DIODE
DIODE
DIODE
LI116
LI116
LI116
LI116
LI116
D324
D325
D326
D331
D332
6-500-131-01
6-500-131-01
6-500-131-01
6-500-260-01
6-500-260-01
DIODE
DIODE
DIODE
DIODE
DIODE
LI116
LI116
LI116
P6SMB39AT3
P6SMB39AT3
D333
D334
D335
D336
D341
6-500-260-01
6-500-260-01
6-500-260-01
6-500-260-01
6-500-260-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
D342
D343
D344
D345
D346
6-500-260-01
6-500-260-01
6-500-260-01
6-500-260-01
6-500-260-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
P6SMB39AT3
D351
D352
D353
D354
D355
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
DIODE
DIODE
DIODE
DIODE
DIODE
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
D356
D361
D362
D363
D364
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
6-500-248-01
DIODE
DIODE
DIODE
DIODE
DIODE
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
SFPL-62V
D365
D366
6-500-248-01 DIODE SFPL-62V
6-500-248-01 DIODE SFPL-62V
< FERRITE BEAD >
FB300
FB301
FB303
FB304
FB307
1-469-760-21
1-469-760-21
1-400-160-51
1-469-760-21
1-469-760-21
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FB308
FB309
FB312
FB313
FB314
1-469-760-21
1-400-160-51
1-400-160-51
1-400-160-51
1-469-760-21
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FERRITE BEAD
FB315
FB318
FB320
1-469-760-21 FERRITE BEAD
122
Remark
Ref. No.
Part No.
Description
Remark
< IC >
IC300
IC301
IC302
IC303
IC304
6-701-189-01
6-701-845-01
8-759-533-85
8-759-460-72
6-701-845-01
IC
IC
IC
IC
IC
MC74VHC1GU04DFT1
CXD9702L
BA05FP-E2
BA033FP-E2
CXD9702L
IC305
IC306
IC307
IC308
IC309
6-700-279-01
6-701-845-01
6-701-845-01
6-700-279-01
6-701-845-01
IC
IC
IC
IC
IC
CXD9634Q
CXD9702L
CXD9702L
CXD9634Q
CXD9702L
IC310
IC311
IC401
6-700-279-01 IC CXD9634Q
6-701-845-01 IC CXD9702L
8-759-385-17 IC NJM4580E (TE2)
< TERMINAL BOARD >
J401
1-694-919-11 TERMINAL BOARD (SPEAKER FRONT L/R,
CENTER, WOOFER, REAR L/R)
< COIL/SHORT >
L300
L302
L401
L402
L403
1-216-295-11
1-412-939-11
1-456-035-11
1-456-035-11
1-456-035-11
SHORT CHIP
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
L404
L405
L406
1-456-035-11 INDUCTOR
1-456-035-11 INDUCTOR
1-456-035-11 INDUCTOR
0
1uH
10uH
10uH
10uH
10uH
10uH
10uH
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-920-75
8-729-920-75
8-729-920-75
8-729-920-75
8-729-920-75
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
Q106
Q107
Q108
Q109
Q110
8-729-920-75
8-729-920-75
8-729-920-75
8-729-920-75
8-729-920-75
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
Q111
Q112
Q113
Q114
Q190
8-729-920-75
8-729-920-75
8-729-901-00
8-729-027-23
8-729-801-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR
2SC2412K-T-146-QR
DTC124EK-T146
DTA114EKA-T146
2SB1013-4
Q191
Q192
8-729-901-00 TRANSISTOR
DTC124EKA-T146
DTC124EKA-T146
< RESISTOR >
R101
R102
R103
R104
R105
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R106
R107
R108
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
100K
5%
5%
5%
1/10W
1/10W
1/10W
HCD-C770/C990
AMP
Ref. No.
Part No.
Description
Remark
R109
R110
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
5%
5%
1/10W
1/10W
R111
R112
R113
R190
R191
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-077-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R300
R301
R302
R304
R305
1-216-833-11
1-216-821-11
1-216-857-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
1M
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R307
R308
R309
R310
R311
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R312
R313
R315
R316
R317
1-216-821-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R318
R319
R320
R321
R322
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R325
R330
R333
R334
R335
1-216-801-11
1-216-809-11
1-216-809-11
1-216-817-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
100
100
470
100
5%
5%
5%
5%
5%
R336
R337
R338
R339
R340
1-216-817-11
1-216-821-11
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
1K
0
100
100
R341
R342
R343
R344
R346
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R347
R348
R349
R350
R370
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-819-11
R395
R396
R397
R398
R399
R470
R471
R472
R473
R474
Ref. No.
AUDIO
Part No.
Description
R475
R480
R481
R482
R483
1-218-725-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
24K
22K
22K
22K
22K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R484
R485
R490
R491
1-216-839-11
1-218-725-11
1-216-833-11
1-216-833-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
33K
24K
10K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< VIBRATOR >
X300
1-795-286-21 VIBRATOR, CRYSTAL (44.152MHz)
**************************************************************
A-4730-641-A AUDIO BOARD, COMPLETE (AEP)
A-4728-875-A AUDIO BOARD, COMPLETE (EXCEPT AEP)
**********************
< CAPACITOR >
C201
330PF
5%
C203
0.1uF
C204
560PF
5%
C205
0.01uF
10%
C206
51PF
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C207
1-126-963-11 ELECT
4.7uF
20%
C208
56PF
5%
C209
1-126-947-11 ELECT
47uF
20%
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C210
C211
1-126-965-11 ELECT
1-126-965-11 ELECT
22uF
22uF
20%
20%
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-162-970-11
1-162-970-11
1-115-156-11
1-115-156-11
1-126-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
0.01uF
1uF
1uF
22uF
10%
10%
100
100
100
100
0
C213
C214
C215
C216
C220
0
100
100
100
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-126-965-11
1-126-965-11
1-164-156-11
1-126-965-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
22uF
22uF
0.1uF
22uF
0.1uF
20%
20%
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
C221
C222
C223
C224
C225
1-216-031-00
1-216-031-00
1-216-031-00
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
180
180
180
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C226
C227
C228
C230
C232
1-164-156-11
1-126-965-11
1-164-156-11
1-126-964-11
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0.1uF
22uF
0.1uF
10uF
10uF
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
22K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C233
C234
C235
C236
C237
1-162-964-11
1-162-964-11
1-126-153-11
1-162-960-11
1-126-153-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
C238
C239
C240
1-126-965-11 ELECT
20%
20%
50V
(AEP)
25V
(AEP)
50V
(AEP)
25V
(AEP)
50V
(AEP)
50V
(AEP)
50V
(AEP)
16V
(AEP)
35V
35V
25V
25V
10V
10V
35V
35V
35V
25V
35V
25V
20%
20%
25V
35V
25V
50V
50V
0.001uF
0.001uF
22uF
220PF
22uF
10%
10%
20%
10%
20%
50V
50V
6.3V
50V
6.3V
220PF
22uF
220PF
10%
20%
10%
50V
35V
50V
20%
123
HCD-C770/C990
AUDIO
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
C241
C242
1-126-965-11 ELECT
22uF
220PF
20%
10%
35V
50V
R209
R210
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
220
220
5%
5%
1/10W
1/10W
C243
C245
C608
C609
1-126-157-11
1-126-964-11
1-162-969-11
1-162-969-11
10uF
10uF
0.0068uF
0.0068uF
20%
20%
10%
10%
16V
50V
25V
25V
R211
R212
R213
R214
R215
1-216-813-11
1-216-813-11
1-216-841-11
1-218-867-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
220
220
47K
6.8K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R216
R217
R218
R219
R220
1-216-829-11
1-216-839-11
1-216-833-11
1-216-809-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
33K
10K
100
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R221
R222
R223
R224
R225
1-216-845-11
1-216-839-11
1-216-833-11
1-216-809-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
33K
10K
100
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R226
R227
R228
R229
R230
1-216-839-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
1K
1K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R231
R232
R233
R235
R236
1-218-285-11
1-218-867-11
1-216-833-11
1-216-841-11
1-216-833-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
75
6.8K
10K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R237
R238
R239
R241
R242
1-218-867-11
1-216-833-11
1-216-821-11
1-216-841-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
10K
1K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R243
R244
R245
R246
R247
1-218-867-11
1-216-833-11
1-216-821-11
1-216-841-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
10K
1K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R249
R250
R251
R252
R253
1-218-867-11
1-216-833-11
1-218-285-11
1-216-833-11
1-216-841-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
6.8K
10K
75
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R254
R290
R291
R292
R293
1-218-285-11
1-216-853-11
1-216-853-11
1-216-821-11
1-216-821-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
75
470K
470K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R294
R295
1-216-815-11 METAL CHIP
1-216-815-11 METAL CHIP
330
330
5%
5%
1/10W
1/10W
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
< CONNECTOR >
CN201
CN202
CN204
CN205
CN208
1-784-733-11
1-779-566-21
1-568-940-11
1-506-481-11
1-779-548-21
CONNECTOR, FFC 11P
PIN, CONNECTOR 2P
PIN, CONNECTOR 2P
< DIODE >
D201
D202
D203
8-719-056-78 DIODE UDZ-TE-17-4.3B (AEP)
8-719-404-50 DIODE MA111-TX
8-719-404-50 DIODE MA111-TX
< IC >
IC201
IC202
8-759-557-36 IC BU1924F-E2 (AEP)
8-759-385-76 IC MC14052 BDR2
< JACK >
J205
J206
1-816-602-11 PIN JACK 6P
(VIDEO 2/COMPONENT VIDEO OUT)
1-816-602-21 PIN JACK 6P (VIDEO 1)
< COIL >
L205
L206
1-469-525-11 INDUCTOR
1-469-525-11 INDUCTOR
10uH (AEP)
10uH
< TRANSISTOR >
Q201
Q205
Q206
Q207
Q208
8-729-120-28
8-729-901-00
8-729-901-00
8-729-920-31
8-729-920-31
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR (AEP)
DTC124EKA-T146
DTC124EKA-T146
DTC343TK-T-146
DTC343TK-T-146
Q220
Q221
Q222
Q223
8-729-901-81
8-729-901-81
8-729-026-50
8-729-901-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SC2412K-T-146-R
2SA1037AK-T146-QR
DTC124EKA-T146
< RESISTOR >
R201
1-216-829-11 METAL CHIP
4.7K
5%
R202
1-216-821-11 METAL CHIP
1K
5%
R203
1-216-843-11 METAL CHIP
68K
5%
R204
1-216-841-11 METAL CHIP
47K
5%
R205
1-216-845-11 METAL CHIP
100K
5%
R206
1-216-853-11 METAL CHIP
470K
5%
R207
1-216-814-11 METAL CHIP
270
5%
R208
1-216-813-11 METAL CHIP
220
5%
124
1/10W
(AEP)
1/10W
(AEP)
1/10W
(AEP)
1/10W
(AEP)
1/10W
(AEP)
1/10W
(AEP)
1/10W
(AEP)
1/10W
< VIBRATOR >
X201
1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz) (AEP)
**************************************************************
HCD-C770/C990
CONTROL
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
1-685-068-11 CONTROL BOARD
***************
DDCON
Description
DVD
Remark
< IC >
R800
R801
R802
R803
R809
1-216-815-11
1-216-817-11
1-216-819-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
470
680
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R837
R844
R849
R860
R873
1-216-815-11
1-216-817-11
1-216-819-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
470
680
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
IC801
8-759-366-45 IC NJU3713G (TE2)
< COIL >
L801
1-412-959-11 INDUCTOR
47uH
< TRANSISTOR >
Q803
Q804
2SD1624-T-TD
2SD1624-T-TD
< RESISTOR >
< SWITCH >
S801
S802
S803
S804
S805
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (H)
SWITCH, KEYBOARD (X)
SWITCH, KEYBOARD (PRESET–, . PREV)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (PRESET+, > NEXT)
S821
1-762-875-21 SWITCH, KEYBOARD (FIELD, +)
S822
1-762-875-21 SWITCH, KEYBOARD (SOUND, –)
S823
1-762-875-21 SWITCH, KEYBOARD (DISPLAY)
S824
1-762-875-21 SWITCH, KEYBOARD (BAND)
S825
1-762-875-21 SWITCH, KEYBOARD (FUNCTION)
**************************************************************
R810
R811
R812
R813
R814
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R838
R841
R842
R843
R850
1-216-805-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47
100
100
100
3.9K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R855
R874
1-216-809-11 METAL CHIP
1-216-839-11 METAL CHIP
100
33K
5%
5%
1/10W
1/10W
A-4676-963-A DDCON BOARD, COMPLETE
**********************
< TRANSFORMER >
< CAPACITOR >
T801
1-437-416-11 TRANSFORMER, DC-DC CONVERTER
**************************************************************
C802
C803
C804
C805
C806
1-162-964-11
1-162-964-11
1-162-970-11
1-162-970-11
1-126-153-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001uF
0.001uF
0.01uF
0.01uF
22uF
10%
10%
10%
10%
20%
50V
50V
25V
25V
6.3V
C820
C821
C822
C823
1-162-970-11
1-124-261-00
1-164-360-11
1-124-261-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
10uF
0.1uF
220uF
10%
20%
25V
50V
16V
16V
20%
< CONNECTOR >
CN802
CN803
* CN804
CN807
CN812
CN814
1-506-481-11
1-779-547-21
1-568-943-11
1-568-940-21
1-779-549-21
PIN, CONNECTOR 2P
CONNECTOR, FFC (LIF (NON-ZIF) 10P
PIN, CONNECTOR 5P
PIN, CONNECTOR 2P
1-779-556-21 CONNECTOR, FFC (LIF (NON-ZIF)) 19P
< DIODE >
D806
D807
D808
D809
D810
8-719-404-50
8-719-404-50
8-719-404-50
8-719-404-50
8-719-069-56
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA111-TX
MA111-TX
MA111-TX
UDZSTE-176.2B
< FERRITE BEAD >
FB800
FB801
FB802
1-414-813-11 FERRITE
1-414-813-11 FERRITE
1-414-813-11 FERRITE
0uH
0uH
0uH
A-4676-951-A
A-4729-049-A
A-4730-636-A
A-4730-646-A
DVD BOARD, COMPLETE (C770: US, CND)
DVD BOARD, COMPLETE (C990)
DVD BOARD, COMPLETE (AEP)
DVD BOARD, COMPLETE (AUS)
*********************
< CAPACITOR >
C001
C003
C004
C005
C006
1-126-206-11
1-126-206-11
1-126-204-11
1-126-246-11
1-126-204-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
100uF
100uF
47uF
220uF
47uF
20%
20%
20%
20%
20%
6.3V
6.3V
16V
4V
16V
C007
C008
C010
C011
C012
1-164-850-11
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
0.1uF
0.1uF
0.1uF
0.1uF
0.5PF
50V
16V
16V
16V
16V
C013
C014
C015
C016
C017
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
C018
C019
C020
C201
C203
1-107-820-11
1-107-820-11
1-126-246-11
1-126-246-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
220uF
220uF
0.01uF
16V
16V
4V
4V
50V
C204
0.01uF
20%
20%
10%
16V
125
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
C217
C219
C225
C226
1-164-947-11
1-164-947-11
1-107-820-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
0.01uF
50V
50V
16V
50V
C228
C229
C230
C231
C232
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C233
C234
C235
C236
C237
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C238
C239
C240
C241
C242
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C243
C244
C245
C246
C247
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C248
C249
C250
C251
C252
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C253
C254
C255
C257
C258
1-164-947-11
1-117-370-11
1-164-947-11
1-117-370-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
10uF
0.01uF
10uF
0.01uF
50V
10V
50V
10V
50V
C259
C260
C261
C262
C263
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
50V
50V
50V
50V
50V
C264
C265
C266
C267
C268
1-117-370-11
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.01uF
0.01uF
0.01uF
0.01uF
10V
50V
50V
50V
50V
C269
C270
C271
C274
C301
1-164-947-11
1-164-947-11
1-164-947-11
1-164-947-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
10uF
50V
50V
50V
50V
10V
C302
C303
C304
C307
C308
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
1-127-772-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
33000PF
10%
10%
10%
10%
10%
16V
16V
16V
16V
10V
C309
C310
C311
C312
1-164-874-11
1-164-874-11
1-164-943-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.01uF
10uF
5%
5%
10%
50V
50V
16V
10V
126
Remark
Ref. No.
Part No.
Description
Remark
C313
0.1uF
16V
C314
C315
C316
C317
C318
1-164-947-11
1-164-947-11
1-124-779-00
1-164-854-11
1-164-852-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
10uF
15PF
12PF
50V
50V
16V
50V
50V
C319
C320
C355
C356
C401
1-164-862-11
1-164-947-11
1-164-947-11
1-164-947-11
1-125-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33PF
0.01uF
0.01uF
0.01uF
0.1uF
10%
50V
50V
50V
50V
6.3V
C402
C404
C405
C406
C407
1-117-370-11
1-125-777-11
1-124-779-00
1-164-939-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
10%
10uF
20%
0.0022uF 10%
10uF
10V
6.3V
16V
50V
10V
C408
C409
C410
C411
C412
1-125-777-11
1-164-939-11
1-124-779-00
1-125-777-11
1-164-939-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.0022uF
10uF
0.1uF
0.0022uF
10%
10%
20%
10%
10%
6.3V
50V
16V
6.3V
50V
C413
C414
C415
C416
C417
1-164-939-11
1-164-943-11
1-164-943-11
1-117-370-11
1-125-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.01uF
0.01uF
10uF
0.1uF
10%
10%
10%
10%
50V
16V
16V
10V
6.3V
C418
C419
C420
C421
C422
1-125-777-11
1-119-923-11
1-164-939-11
1-125-777-11
1-164-874-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.047uF
0.0022uF
0.1uF
100PF
10%
10%
10%
10%
5%
6.3V
10V
50V
6.3V
50V
C423
C424
C425
C426
C427
1-125-777-11
1-107-819-11
1-164-939-11
1-164-943-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.022uF
0.0022uF
0.01uF
0.47uF
10%
10%
10%
10%
10%
6.3V
16V
50V
16V
10V
C428
C432
C433
C434
C435
1-164-939-11
1-164-874-11
1-164-938-11
1-117-370-11
1-125-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
100PF
0.0015uF
10uF
0.1uF
10%
5%
10%
10%
50V
50V
50V
10V
6.3V
C436
C503
C504
C506
C508
1-125-777-11
1-127-772-11
1-127-772-11
1-164-934-11
1-164-937-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
33000PF
33000PF
330PF
0.001uF
10%
10%
10%
10%
10%
6.3V
10V
10V
50V
50V
C509
C510
C512
C514
C519
1-164-934-11
1-164-937-11
1-164-943-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
0.001uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
50V
16V
16V
16V
C521
C523
C525
C526
C527
1-164-938-11
1-164-938-11
1-125-777-11
1-126-395-11
1-125-777-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.0015uF
0.0015uF
0.1uF
22uF
0.1uF
10%
10%
10%
20%
10%
50V
50V
6.3V
16V
6.3V
C528
1-126-395-11 ELECT
22uF
20%
16V
20%
5%
5%
5%
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
C529
C552
C600
C601
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
Remark
C602
C603
C604
C605
C606
1-117-681-11
1-164-858-11
1-164-868-11
1-107-820-11
1-126-206-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
100uF
22PF
56PF
0.1uF
100uF
C607
C608
C609
C610
C611
1-107-820-11
1-107-820-11
1-107-820-11
1-126-205-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
47uF
0.01uF
C612
C613
C614
C615
C616
1-117-370-11
1-117-370-11
1-124-779-00
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
10uF
0.1uF
0.1uF
C617
C618
C619
C620
C621
1-107-820-11
1-124-779-00
1-107-820-11
1-107-820-11
1-164-935-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
0.1uF
0.1uF
470PF
C622
C623
C624
C625
C626
1-124-779-00
1-164-850-11
1-107-820-11
1-124-779-00
1-164-947-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
10uF
10PF
0.1uF
10uF
0.01uF
C627
C628
C629
C630
C631
1-164-947-11
1-124-779-00
1-164-935-11
1-117-370-11
1-107-820-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
10uF
470PF
10uF
0.1uF
C632
C633
C634
C635
C636
1-164-947-11
1-107-820-11
1-107-820-11
1-164-947-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.01uF
0.1uF
50V
16V
16V
50V
16V
C637
C638
C639
C640
C641
1-164-947-11
1-107-820-11
1-107-820-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.01uF
0.01uF
50V
16V
16V
50V
50V
C642
C643
C644
C645
C646
1-164-947-11
1-126-246-11
1-164-947-11
1-164-882-11
1-164-947-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
220uF
0.01uF
220PF
0.01uF
C647
C648
C650
C651
C652
1-164-947-11
1-107-820-11
1-164-947-11
1-164-947-11
1-126-246-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.01uF
0.1uF
0.01uF
0.01uF
220uF
C653
C654
C655
C656
1-164-947-11
1-117-681-11
1-126-206-11
1-107-820-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
100uF
100uF
0.1uF
16V
16V
16V
16V
20%
5%
5%
20%
20%
20%
20%
10%
20%
0.5PF
20%
20%
10%
20%
5%
20%
20%
20%
16V
50V
50V
16V
6.3V
16V
16V
16V
6.3V
50V
10V
10V
16V
16V
16V
16V
16V
16V
16V
50V
16V
50V
16V
16V
50V
50V
16V
50V
10V
16V
50V
4V
50V
16V
50V
50V
16V
50V
50V
4V
50V
16V
6.3V
16V
Ref. No.
Part No.
Description
Remark
C657
0.1uF
16V
C658
C659
C660
C661
C662
1-164-935-11
1-164-882-11
1-164-947-11
1-164-947-11
1-164-882-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
220PF
0.01uF
0.01uF
220PF
10%
5%
C663
C667
C668
C669
C670
1-164-935-11
1-117-370-11
1-164-947-11
1-164-947-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
10uF
0.01uF
0.01uF
0.01uF
10%
C671
C672
C673
C674
C675
1-164-947-11
1-164-947-11
1-164-947-11
1-117-370-11
1-164-947-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
10uF
0.01uF
50V
50V
50V
10V
50V
C676
C677
C678
C679
C702
1-164-947-11
1-164-947-11
1-164-882-11
1-164-947-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
220PF
0.01uF
10uF
5%
50V
50V
16V
50V
10V
C703
C706
C708
C709
C711
1-107-820-11
1-107-820-11
1-164-937-11
1-107-820-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.001uF
0.1uF
0.01uF
10%
10%
16V
16V
50V
16V
16V
C712
C713
C714
C715
C716
1-164-882-11
1-107-820-11
1-107-820-11
1-164-938-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
5%
0.1uF
0.1uF
0.0015uF 10%
0.47uF
10%
16V
16V
16V
50V
10V
C717
C718
C720
C721
C722
1-164-943-11
1-107-820-11
1-125-777-11
1-125-777-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
6.3V
6.3V
16V
C723
C724
C725
C726
C727
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10uF
C728
C729
C730
C740
C741
1-125-777-11
1-117-370-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
0.1uF
0.1uF
0.1uF
C742
C743
C744
C745
C752
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
C760
C761
C762
C763
C764
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
C765
0.1uF
16V
5%
10%
10%
10%
50V
16V
50V
50V
16V
50V
10V
50V
50V
50V
16V
16V
16V
16V
10V
10%
6.3V
10V
16V
16V
16V
127
HCD-C770/C990
DVD
Ref. No.
Remark
Ref. No.
Part No.
Description
Remark
Part No.
Description
C766
C767
C768
C769
1-164-874-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
0.1uF
0.1uF
C770
C771
C772
C773
C774
1-107-820-11
1-119-923-11
1-107-820-11
1-125-891-11
1-164-941-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.047uF 10%
0.1uF
0.47uF
10%
0.0047uF 10%
16V
10V
16V
10V
16V
C775
C776
C777
C778
C779
1-107-820-11
1-107-820-11
1-107-820-11
1-107-820-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
10uF
16V
16V
16V
16V
10V
C780
C781
C791
C793
C795
1-117-370-11
1-117-370-11
1-126-206-11
1-126-246-11
1-126-206-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
10uF
10uF
100uF
220uF
100uF
10V
10V
6.3V
4V
6.3V
C796
C797
C802
C803
C804
1-107-820-11
1-126-246-11
1-117-370-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220uF
10uF
0.01uF
0.01uF
10%
10%
16V
4V
10V
16V
16V
C807
C808
C809
C810
C811
1-164-943-11
1-164-874-11
1-164-943-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
100PF
0.01uF
0.01uF
0.01uF
10%
5%
10%
10%
10%
16V
50V
16V
16V
16V
C812
C813
C815
C817
C818
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C819
C837
C838
C839
C840
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
1-117-370-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
10uF
10%
10%
10%
10%
16V
16V
16V
16V
10V
C841
C842
C843
C848
C849
1-117-370-11
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10V
16V
16V
16V
16V
C854
C855
C856
C857
C861
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
FB001
FB003
FB004
FB005
FB006
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0uH
0uH
0uH
0uH
0uH
C865
C866
C867
C870
C871
1-164-943-11
1-164-943-11
1-164-943-11
1-127-772-11
1-164-943-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
33000PF
0.01uF
10%
10%
10%
10%
10%
16V
16V
16V
10V
16V
FB007
FB008
FB009
FB010
FB011
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0uH
0uH
0uH
0uH
0uH
C900
C901
C902
C903
1-107-820-11
1-164-943-11
1-107-820-11
1-126-206-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
0.01uF
0.1uF
100uF
16V
16V
16V
6.3V
FB012
FB013
FB014
FB201
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
FERRITE
FERRITE
FERRITE
FERRITE
0uH
0uH
0uH
0uH
5%
20%
20%
20%
20%
50V
16V
16V
16V
C905
330PF
10%
50V
C906
C907
C908
C909
C910
1-164-934-11
1-164-937-11
1-164-874-11
1-164-222-91
1-104-905-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
DOUBLE LAYER
330PF
0.001uF
100PF
0.22uF
0.22F
10%
10%
5%
50V
50V
50V
25V
5.5V
C911
C912
C913
C914
C917
1-126-205-11
1-126-205-11
1-164-943-11
1-164-943-11
1-107-820-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
0.01uF
0.01uF
0.1uF
20%
20%
10%
10%
6.3V
6.3V
16V
16V
16V
C918
C921
C922
C923
C924
1-164-874-11
1-164-874-11
1-107-820-11
1-107-820-11
1-107-820-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.1uF
0.1uF
0.1uF
5%
5%
50V
50V
16V
16V
16V
C925
C926
C927
0.1uF
0.1uF
0.1uF
< CONNECTOR >
CN001
CN002
CN003
CN004
CN005
1-784-371-31
1-778-957-11
1-784-373-31
1-784-376-31
1-778-691-11
CONNECTOR, FFC/FPC 12P
CN006
CN008
CN201
* CN301
CN401
1-784-385-31
1-815-954-21
1-784-364-31
1-580-756-21
1-778-957-11
PIN, CONNECTOR (PC BOARD) 13P
PIN, CONNECTOR (SMD) 7P
CN900
1-784-367-31 CONNECTOR, FFC/FPC 8P
< DIODE >
128
10%
20%
D900
D901
D902
D903
D904
8-719-053-18
8-719-053-18
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SR154-400TE-25
1SR154-400TE-25
1SS355TE-17
1SS355TE-17
1SS355TE-17
D906
D907
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
< FERRITE BEAD >
16V
16V
16V
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
FB202
1-469-324-21 FERRITE
0uH
IC607
8-759-698-76 IC CXD9617R
FB901
FB902
1-469-324-21 FERRITE
1-469-324-21 FERRITE
0uH
0uH
IC608
IC610
IC612
IC701
IC702
6-701-111-01
8-759-337-40
6-700-278-01
8-752-412-43
8-759-637-50
IC
IC
IC
IC
IC
AK4382AVT-E2
NJM2904V (TE2)
CXD9633Q
CXD1882R
TA48M025F (TE16L)
IC703
IC706
IC801
IC802
IC803
8-759-058-43
8-759-564-30
8-752-407-50
8-759-058-64
6-702-563-01
IC
IC
IC
IC
IC
NJM3404AV (TE2)
MSM51V18165F-60TSKR1
CXD2752R
TC7S32FU (TE85R)
TC7W74FK-TE85L
IC808
IC812
IC813
IC814
IC900
6-702-336-01
8-759-549-15
8-759-549-15
8-759-680-48
8-759-238-47
IC
IC
IC
IC
IC
MSM56V16160F-8TK7R1
SN74LV245APWR
SN74LV245APWR
TC7WH157FK (TE85R)
TC74HCT7007AF (EL)
IC901
IC902
IC903
IC904
IC905
6-801-944-01
8-759-828-32
8-759-427-92
8-759-326-78
8-759-234-20
IC
IC
IC
IC
IC
uPD703033BYGF-M01-3BA
PT8300
PST9126NL
PST9140NL
TC7S08F-TE85L
IC906
IC907
8-759-828-32 IC PT8300
8-759-326-78 IC PST9140NL
< FILTER/FERRITE BEAD >
FL003
FL004
FL005
FL006
FL202
1-234-177-21
1-234-177-21
1-233-893-21
1-234-177-21
1-233-893-21
FERRITE
0uH
FERRITE
0uH
FILTER, CHIP EMI
FERRITE
0uH
FILTER, CHIP EMI
FL203
FL204
FL301
FL303
FL304
1-233-893-21
1-233-893-21
1-233-893-21
1-233-893-21
1-233-893-21
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FL401
FL402
FL603
FL604
FL605
1-233-893-21
1-233-893-21
1-234-177-21
1-234-177-21
1-234-177-21
FILTER, CHIP EMI
FILTER, CHIP EMI
FERRITE
0uH
FERRITE
0uH
FERRITE
0uH
FL606
FL701
FL702
FL703
FL704
1-234-177-21
1-233-893-21
1-233-893-21
1-233-893-21
1-233-893-21
FERRITE
0uH
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FL705
FL706
FL807
FL810
FL811
1-233-893-21
1-233-893-21
1-233-893-21
1-233-893-21
1-233-893-21
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FILTER, CHIP EMI
FL812
1-233-893-21 FILTER, CHIP EMI
< RESISTOR >
JW900
JW903
1-218-941-81 RES-CHIP
1-218-990-11 SHORT CHIP
100
0
5%
1/16W
< COIL >
L301
L600
L602
1-414-754-11 INDUCTOR
1-414-754-11 INDUCTOR
1-414-754-11 INDUCTOR
10uH
10uH
10uH
< IC >
< TRANSISTOR >
IC001
IC002
IC003
IC004
IC005
8-759-583-47
8-759-473-95
8-759-473-95
8-759-473-95
8-759-583-47
IC
IC
IC
IC
IC
uPC2933T-E2
uPC2905T-E1
uPC2905T-E1
uPC2905T-E1
uPC2933T-E2
IC006
IC202
IC203
IC204
IC206
6-700-398-01
6-702-368-01
8-759-668-01
6-802-150-01
6-700-404-01
IC
IC
IC
IC
IC
uPC2918T-E1
MT48LC4M32B2-7
BR9040F-D-E2
MR27V3202F-8PTPZ020
ZIVA-5P-B0
IC215
IC301
IC302
IC303
IC401
6-700-437-01
8-752-931-99
8-759-640-41
6-700-406-01
8-752-408-73
IC
IC
IC
IC
IC
SN74ALVCH16841DGGR
CXP973064-220R
BR24C08F-E2
IMIC6007BT-D
CXD3068Q
IC402
IC501
IC600
IC601
IC602
8-759-058-43
6-702-157-01
8-759-052-52
6-701-011-01
8-759-560-56
IC
IC
IC
IC
IC
NJM3404AV (TE2)
FAN8035L
NJM78M05DL1A-TE1
uPC2910T-E1
PCM1800E/2K
IC603
IC604
IC605
IC606
8-759-337-40
8-759-538-16
8-759-835-63
8-759-825-15
IC
IC
IC
IC
NJM2904V (TE2)
IDT71V016S15PH-AUTL
NJM2391DL1-26 (TE1)
LC89056W-E
Q001
Q002
Q003
Q004
Q301
8-729-901-00
6-550-220-01
8-729-901-00
6-550-220-01
8-729-900-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124EKA-T146
2SB906 (TE16L)
DTC124EKA-T146
2SB906 (TE16L)
DTC114EKA-T146
Q302
Q900
Q901
Q902
Q903
8-729-900-53
8-729-027-23
8-729-230-63
8-729-027-23
8-729-024-91
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTA114EKA-T146
2SD1819A-QRS-TX
DTA114EKA-T146
2SC2712-GL-TE85L
Q906
Q907
Q908
Q909
Q910
8-729-024-91
8-729-024-91
8-729-901-00
8-729-901-00
8-729-901-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712-GL-TE85L
2SC2712-GL-TE85L
DTC124EKA-T146
DTC124EKA-T146
DTC124EKA-T146
Q911
Q912
Q913
Q914
8-729-901-00
8-729-024-91
8-729-026-49
8-729-024-91
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124EKA-T146
2SC2712-GL-TE85L
2SA1037AK-T146-QR
2SC2712-GL-TE85L
< RESISTOR >
R001
R002
1-218-990-11 SHORT CHIP
1-218-990-11 SHORT CHIP
0
0
129
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
R003
R004
R005
1-218-990-11 SHORT CHIP
1-218-990-11 SHORT CHIP
1-218-990-11 SHORT CHIP
0
0
0
R006
R007
R009
R011
R012
1-218-990-11
1-218-990-11
1-218-953-11
1-216-198-00
1-218-990-11
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
0
0
1K
1K
0
R013
R014
R015
R016
R017
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R018
R019
R020
R021
R022
1-218-990-11
1-218-957-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
2.2K
0
0
0 (AEP)
R023
R024
R025
R026
R027
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0 (AEP)
0
0
0
R028
R029
R030
R031
R032
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R033
R034
R035
R036
R037
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R038
R039
R040
R041
R042
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R043
R044
R045
R046
R047
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R048
R049
R050
R051
R052
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R053
R054
R055
R056
R057
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R058
R059
R060
R061
R062
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
130
5%
5%
5%
1/16W
1/8W
1/16W
Ref. No.
Part No.
Description
Remark
R063
R064
R065
R066
R067
1-218-990-11
1-218-990-11
1-218-990-11
1-218-953-11
1-218-949-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
0
0
0
1K
470
R068
R069
R070
R071
R073
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R074
R075
R076
R079
R202
1-218-990-11
1-218-990-11
1-218-990-11
1-216-198-00
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
0
0
0
1K
0
R203
R206
R207
R208
R209
1-208-869-11
1-218-990-11
1-218-285-11
1-218-285-11
1-218-285-11
METAL CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
R210
R211
R212
R213
R214
1-218-285-11
1-218-990-11
1-208-643-11
1-218-990-11
1-218-990-11
R215
R216
R217
R218
R219
5%
5%
1/16W
1/16W
5%
1/8W
180
0
75
75
75
0.5%
1/16W
5%
5%
5%
1/10W
1/10W
1/10W
RES-CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
75
0
22
0
0
5%
1/10W
5%
1/16W
1-218-935-11
1-218-935-11
1-218-935-11
1-218-935-11
1-218-935-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33
33
33
33
33
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R220
R221
R222
R223
R224
1-218-935-11
1-218-935-11
1-218-935-11
1-218-935-11
1-218-935-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33
33
33
33
33
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R225
R226
R227
R228
R229
1-218-935-11
1-218-961-11
1-218-935-11
1-218-935-11
1-218-935-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33
4.7K
33
33
33
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R230
R231
R232
R233
R234
1-218-935-11
1-218-935-11
1-218-990-11
1-218-965-11
1-218-285-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
33
33
0
10K
75
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/10W
R235
R236
R238
R239
R241
1-218-990-11
1-208-683-11
1-218-941-81
1-218-973-11
1-218-965-11
SHORT CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
1K
100
47K
10K
0.5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R242
R243
R244
R245
R246
1-218-965-11
1-218-965-11
1-218-961-11
1-218-961-11
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
4.7K
4.7K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R247
R248
1-218-961-11 RES-CHIP
1-218-961-11 RES-CHIP
4.7K
4.7K
5%
5%
1/16W
1/16W
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
R249
R250
R251
1-218-961-11 RES-CHIP
1-218-961-11 RES-CHIP
1-218-965-11 RES-CHIP
4.7K
4.7K
10K
5%
5%
5%
1/16W
1/16W
1/16W
R252
R253
R256
R257
R258
1-218-961-11
1-218-961-11
1-218-961-11
1-216-864-11
1-216-864-11
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/10W
R259
R260
R261
R262
R263
1-216-864-11
1-216-864-11
1-216-864-11
1-218-285-11
1-218-285-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
0
0
0
75
75
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R264
R265
R266
R303
R304
1-218-285-11
1-218-285-11
1-218-285-11
1-208-643-11
1-208-643-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
75
75
75
22
22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R305
R306
R307
R308
R309
1-218-965-11
1-208-643-11
1-208-643-11
1-208-643-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
22
22
22
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R311
R312
R313
R314
R315
1-208-643-11
1-218-965-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
22
10K
0
0
0
5%
5%
1/16W
1/16W
R316
R317
R318
R319
R320
1-218-965-11
1-218-941-81
1-218-941-81
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
10K
100
100
0
0
5%
5%
5%
R321
R322
R323
R324
R326
1-218-941-81
1-218-990-11
1-218-941-81
1-218-990-11
1-218-941-81
RES-CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
100
0
100
0
100
5%
1/16W
5%
1/16W
5%
1/16W
R327
R328
R329
R330
R331
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-945-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R332
R333
R335
R336
R337
1-218-965-11
1-218-965-11
1-208-643-11
1-218-990-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
10K
10K
22
0
100
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R338
R339
R340
R341
R342
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R344
R345
R346
R349
R350
1-218-953-11
1-218-990-11
1-218-953-11
1-218-990-11
1-218-941-81
RES-CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
1K
0
1K
0
100
1/16W
1/16W
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
Ref. No.
Part No.
Description
Remark
R351
R352
R353
R354
R355
1-218-990-11
1-218-990-11
1-218-965-11
1-218-989-11
1-208-643-11
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
0
10K
1M
22
5%
5%
5%
1/16W
1/16W
1/16W
R356
R357
R358
R359
R360
1-218-939-11
1-218-939-11
1-218-939-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
68
68
68
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R361
R362
R363
R364
R401
1-218-965-11
1-218-948-11
1-218-965-11
1-218-961-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
390
10K
4.7K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R402
R403
R404
R405
R406
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R407
R408
R409
R410
R411
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R412
R413
R415
R416
R417
1-218-965-11
1-218-965-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
10K
10K
0
0
0
5%
5%
1/16W
1/16W
R418
R419
R420
R421
R423
1-218-965-11
1-218-975-11
1-218-990-11
1-218-953-11
1-218-953-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
10K
68K
0
1K
1K
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R424
R425
R426
R427
R428
1-218-990-11
1-218-953-11
1-218-953-11
1-218-990-11
1-218-953-11
SHORT CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
0
1K
1K
0
1K
5%
5%
1/16W
1/16W
5%
1/16W
R429
R430
R431
R432
R433
1-218-953-11
1-218-953-11
1-218-990-11
1-218-990-11
1-218-973-11
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
1K
1K
0
0
47K
5%
5%
1/16W
1/16W
5%
1/16W
R434
R435
R436
R437
R438
1-218-973-11
1-218-990-11
1-218-990-11
1-218-973-11
1-218-990-11
RES-CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
47K
0
0
47K
0
5%
1/16W
5%
1/16W
R439
R440
R441
R442
R443
1-218-947-11
1-218-973-11
1-218-953-11
1-218-965-11
1-218-973-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
330
47K
1K
10K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R444
R445
1-218-985-11 RES-CHIP
1-218-953-11 RES-CHIP
470K
1K
5%
5%
1/16W
1/16W
131
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
R446
R447
R448
1-218-965-11 RES-CHIP
1-218-965-11 RES-CHIP
1-218-953-11 RES-CHIP
10K
10K
1K
5%
5%
5%
1/16W
1/16W
1/16W
R449
R450
R451
R452
R453
1-218-971-11
1-218-953-11
1-218-965-11
1-218-989-11
1-218-989-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33K
1K
10K
1M
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R455
R457
R510
R511
R512
1-218-977-11
1-218-959-11
1-208-939-11
1-208-939-11
1-218-974-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
3.3K
150K
150K
56K
5%
5%
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R513
R516
R517
R519
R520
1-218-974-11
1-218-961-11
1-218-957-11
1-218-977-11
1-218-965-11
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
56K
4.7K
2.2K
100K
10K
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R521
R522
R523
R524
R525
1-218-977-11
1-218-961-11
1-218-965-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
4.7K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R527
R528
R529
R530
R531
1-218-957-11
1-218-990-11
1-218-971-11
1-218-974-11
1-218-990-11
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
2.2K
0
33K
56K
0
5%
1/16W
5%
5%
1/16W
1/16W
R532
R533
R534
R535
R536
1-218-990-11
1-218-971-11
1-218-974-11
1-218-990-11
1-220-210-11
SHORT CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
0
33K
56K
0
200K
5%
5%
1/16W
1/16W
5%
1/16W
R538
R540
R541
R544
R545
1-218-977-11
1-218-965-11
1-218-977-11
1-218-977-11
1-218-977-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
10K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R553
R554
R579
R580
R581
1-218-990-11
1-218-990-11
1-218-964-11
1-218-971-11
1-218-966-81
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
0
8.2K
33K
12K
5%
5%
5%
1/16W
1/16W
1/16W
R582
R583
R598
R600
R602
1-218-965-11
1-218-965-11
1-218-990-11
1-218-941-81
1-218-989-11
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
10K
10K
0
100
1M
5%
5%
1/16W
1/16W
5%
5%
1/16W
1/16W
R603
R604
R605
R606
R607
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R608
R609
R610
R611
R612
1-218-959-11
1-218-949-11
1-218-957-11
1-218-941-81
1-218-973-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
470
2.2K
100
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
132
Ref. No.
Part No.
Description
Remark
R613
R614
R615
R616
R617
1-218-961-11
1-218-971-11
1-218-961-11
1-218-962-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
4.7K
33K
4.7K
5.6K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R618
R619
R620
R621
R622
1-218-961-11
1-218-973-11
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.7K
47K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R623
R624
R625
R626
R627
1-218-941-81
1-218-941-81
1-218-959-11
1-218-953-11
1-218-957-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
3.3K
1K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R628
R629
R630
R631
R634
1-218-941-81
1-218-941-81
1-218-949-11
1-218-941-81
1-218-953-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
470
100
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R635
R636
R637
R639
R640
1-218-965-11
1-218-961-11
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
4.7K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R642
R644
R645
R646
R647
1-218-941-81
1-218-965-11
1-218-965-11
1-218-961-11
1-218-945-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
10K
10K
4.7K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R648
R649
R650
R651
R652
1-218-941-81
1-218-961-11
1-218-961-11
1-218-965-11
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
4.7K
4.7K
10K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R653
R654
R655
R656
R657
1-218-961-11
1-218-945-11
1-218-941-81
1-218-990-11
1-218-953-11
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
4.7K
220
100
0
1K
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R658
R659
R660
R661
R662
1-218-941-81
1-218-935-11
1-218-945-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
33
220
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R663
R664
R665
R666
R667
1-218-941-81
1-218-941-81
1-218-965-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R668
R669
R671
R672
R673
1-218-953-11
1-218-953-11
1-218-941-81
1-218-941-81
1-218-945-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
100
100
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R674
R675
1-218-945-11 RES-CHIP
1-218-945-11 RES-CHIP
220
220
5%
5%
1/16W
1/16W
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
R676
R677
R679
1-218-945-11 RES-CHIP
1-218-945-11 RES-CHIP
1-218-941-81 RES-CHIP
220
220
100
5%
5%
5%
1/16W
1/16W
1/16W
R680
R682
R684
R685
R686
1-218-941-81
1-218-965-11
1-218-965-11
1-218-953-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
10K
10K
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R687
R688
R689
R692
R695
1-218-953-11
1-218-965-11
1-218-965-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
10K
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R696
R699
R700
R702
R703
1-218-945-11
1-218-941-81
1-218-965-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
220
100
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R704
R705
R706
R707
R708
1-218-965-11
1-218-965-11
1-218-965-11
1-218-941-81
1-218-989-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
10K
100
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R709
R710
R711
R712
R713
1-218-975-11
1-218-965-11
1-218-957-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
68K
10K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R714
R715
R716
R717
R718
1-218-965-11
1-218-965-11
1-218-941-81
1-218-977-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
100
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R719
R720
R721
R724
R725
1-218-953-11
1-218-953-11
1-208-719-11
1-208-683-11
1-208-689-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
33K
1K
1.8K
5%
5%
0.5%
0.5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R726
R727
R728
R729
R730
1-208-935-11
1-208-695-11
1-208-707-11
1-218-964-11
1-208-643-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100K
3.3K
10K
8.2K
22
0.5%
0.5%
0.5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R731
R732
R735
R737
R738
1-208-643-11
1-218-965-11
1-218-965-11
1-218-965-11
1-208-643-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22
10K
10K
10K
22
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R741
R742
R743
R744
R745
1-208-643-11
1-208-643-11
1-208-643-11
1-208-643-11
1-218-973-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22
22
22
22
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R746
R747
R748
R750
R752
1-218-973-11
1-218-971-11
1-218-971-11
1-218-965-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
47K
33K
33K
10K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
Remark
R753
R754
R755
R756
R757
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R758
R759
R762
R763
R764
1-218-990-11
1-218-990-11
1-218-969-11
1-218-964-11
1-218-989-11
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
0
22K
8.2K
1M
R765
R766
R767
R770
R771
1-218-969-11
1-218-990-11
1-218-973-11
1-218-990-11
1-218-957-11
RES-CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
22K
0
47K
0
2.2K
R772
R775
R776
R777
R778
1-208-643-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-977-11
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
22
0
0
0
100K
R780
R781
R799
R800
R803
1-218-990-11
1-218-990-11
1-218-990-11
1-218-961-11
1-218-941-81
SHORT CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
R804
R805
R821
R822
R823
1-218-990-11
1-218-965-11
1-208-643-11
1-208-643-11
1-208-643-11
R826
R827
R828
R829
R830
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
0
0
0
4.7K
100
5%
5%
1/16W
1/16W
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
10K
22
22
22
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1-208-643-11
1-218-941-81
1-218-961-11
1-218-941-81
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22
100
4.7K
100
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R831
R833
R834
R835
R836
1-218-971-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
33K
0
0
0
0
5%
1/16W
R837
R838
R839
R840
R841
1-218-990-11
1-218-990-11
1-218-961-11
1-218-990-11
1-218-990-11
SHORT CHIP
SHORT CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
0
0
4.7K
0
0
5%
1/16W
R842
R843
R844
R845
R846
1-218-965-11
1-218-990-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
10K
0
0
0
0
5%
1/16W
R847
R848
R849
R850
R851
1-208-643-11
1-208-643-11
1-208-643-11
1-208-643-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
22
22
22
22
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R852
R865
1-218-990-11 SHORT CHIP
1-218-990-11 SHORT CHIP
0
0
133
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
R866
R867
R882
1-218-990-11 SHORT CHIP
1-218-990-11 SHORT CHIP
1-218-965-11 RES-CHIP
0
0
10K
5%
1/16W
R883
R884
R885
R886
R887
1-218-965-11
1-218-965-11
1-218-965-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R888
R889
R899
R900
R901
1-218-965-11
1-218-965-11
1-218-957-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
2.2K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R902
R903
R904
R905
R906
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-959-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R907
R908
R909
R910
R911
1-218-959-11
1-218-965-11
1-218-965-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
3.3K
10K
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R912
R913
R914
R915
R916
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R917
R918
R919
R920
R921
1-218-952-11
1-218-952-11
1-218-965-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
820
820
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R922
R924
R925
R926
R927
1-218-965-11
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R928
R929
R930
R931
R932
1-218-990-11
1-218-967-11
1-218-965-11
1-218-953-11
1-218-965-11
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
15K
10K
1K
10K
5%
5%
5%
5%
R933
R934
R935
1-218-965-11 RES-CHIP
1-218-965-11 RES-CHIP
1-218-961-11 RES-CHIP
10K
10K
4.7K
5%
5%
5%
R935
1-218-965-11 RES-CHIP
10K
R936
1-218-953-11 RES-CHIP
1K
1/16W
1/16W
1/16W
(C990)
5%
1/16W
(C770: US, CND)
5%
1/16W
R937
R938
R939
R940
R941
1-218-965-11
1-218-965-11
1-218-965-11
1-218-941-81
1-218-959-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
10K
100
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R942
R943
R944
1-218-959-11 RES-CHIP
1-218-959-11 RES-CHIP
1-218-965-11 RES-CHIP
3.3K
3.3K
10K
5%
5%
5%
1/16W
1/16W
1/16W
134
1/16W
1/16W
1/16W
1/16W
Ref. No.
Part No.
Description
Remark
R945
R946
1-218-965-11 RES-CHIP
1-218-965-11 RES-CHIP
10K
10K
5%
5%
1/16W
1/16W
R948
R949
R950
R951
R953
1-218-965-11
1-218-965-11
1-218-973-11
1-218-965-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
47K
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R954
R955
R956
R957
R959
1-218-965-11
1-218-965-11
1-218-965-11
1-218-965-11
1-218-953-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
10K
10K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R960
R961
R962
R963
1-218-965-11
1-218-965-11
1-218-965-11
1-218-957-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
10K
10K
2.2K
5%
5%
5%
5%
R963
1-218-961-11 RES-CHIP
4.7K
5%
1/16W
1/16W
1/16W
1/16W
(US, CND)
1/16W
(AUS)
R964
R965
R966
R967
R968
1-218-973-11
1-218-965-11
1-218-945-11
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
10K
220
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R969
1-218-947-11 RES-CHIP
330
5%
R970
R971
R972
R974
1-218-965-11
1-218-965-11
1-218-965-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
10K
10K
0
5%
5%
5%
1/16W
(C990)
1/16W
1/16W
1/16W
R977
R978
R979
R980
R981
1-218-969-11
1-218-953-11
1-218-973-11
1-218-973-11
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
22K
1K
47K
47K
4.7K
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
(EXCEPT AUS)
R981
1-218-955-11 RES-CHIP
1.5K
5%
R983
R984
R985
R986
1-218-973-11
1-218-973-11
1-218-985-11
1-218-973-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
47K
470K
47K
5%
5%
5%
5%
1/16W
(AUS)
1/16W
1/16W
1/16W
1/16W
R987
R988
R989
R990
R991
1-218-973-11
1-218-990-11
1-218-990-11
1-218-967-11
1-218-965-11
RES-CHIP
SHORT CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
47K
0
0
15K
10K
5%
1/16W
5%
5%
1/16W
1/16W
R992
R993
R998
R999
1-218-965-11
1-218-953-11
1-218-965-11
1-218-955-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
1K
10K
1.5K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
< COMPOSITION CIRCUIT BLOCK >
* RB901
* RB902
1-233-270-11 NETWORK, RES (8 GANG) 10K
1-233-270-11 NETWORK, RES (8 GANG) 10K
< VIBRATOR >
X301
1-781-945-21 VIBRATOR, CERAMIC (20MHz)
HCD-C770/C990
DVD
Ref. No.
Part No.
Description
Remark
X302
1-795-630-11 VIBRATOR, CRYSTAL (27MHz)
X600
1-781-465-21 VIBRATOR, CRYSTAL (12.288MHz)
X601
1-795-363-21 VIBRATOR, CERAMIC (13.5MHz)
X901
1-781-945-21 VIBRATOR, CERAMIC (20MHz)
**************************************************************
1-685-886-11 FL BOARD
********
Ref. No.
Part No.
FL
HP
Description
KEY
Remark
< COIL >
L900
L901
L902
L903
1-410-387-11
1-410-387-11
1-469-144-21
1-469-144-21
INDUCTOR CHIP
INDUCTOR CHIP
FERRITE
FERRITE
33uH
33uH
0uH
0uH
< TRANSISTOR >
4-240-402-01 FL HOLDER
Q900
Q901
< CAPACITOR >
C808
C809
C812
C813
C814
1-162-970-11
1-126-153-11
1-124-589-11
1-164-360-11
1-162-964-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
22uF
47uF
0.1uF
0.001uF
C815
C816
C817
C818
C819
1-162-927-11
1-162-964-11
1-162-964-11
1-162-923-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.001uF
0.001uF
47PF
0.1uF
10%
20%
20%
10%
5%
10%
10%
5%
25V
6.3V
16V
16V
50V
50V
50V
50V
50V
16V
DTC343TK-T-146
DTC343TK-T-146
< RESISTOR >
R900
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
R901
1-216-807-11 METAL CHIP
68
5%
1/10W
R902
1-216-807-11 METAL CHIP
68
5%
1/10W
R903
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
**************************************************************
A-4728-876-A KEY BOARD, COMPLETE
*********************
< CONNECTOR >
< CONNECTOR >
CN811
CN805
1-779-547-21 CONNECTOR, FFC (LIF (NON-ZIF) 10P
< LED >
< FLUORESCENT INDICATOR TUBE >
FL801
D801
D802
D803
D804
D805
1-518-824-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC101
IC802
8-759-827-68 IC NJL62H400A-1
6-700-112-01 IC MSM9202-05GS-KDR1
R815
1-216-805-11 METAL CHIP
47
5%
1/10W
R839
1-216-833-11 METAL CHIP
10K
5%
1/10W
R840
1-216-827-11 METAL CHIP
3.3K
5%
1/10W
**************************************************************
1-685-887-11 HP BOARD
*********
< CAPACITOR >
1-162-970-11
1-162-970-11
1-164-360-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
< CONNECTOR >
* CN900
1-506-987-11 PIN, CONNECTOR (PC BOARD) 5P
< FERRITE BEAD >
FB803
FB804
FB805
1-469-144-21 FERRITE
1-469-144-21 FERRITE
1-469-144-21 FERRITE
< JACK >
J900
1-566-891-21 JACK (PHONES)
0uH
0uH
0uH
LED
LED
LED
LED
LED
SML-020MDT-T86 (DISC1)
< RESISTOR >
< RESISTOR >
C902
C903
C904
C991
C992
8-719-079-89
8-719-079-89
8-719-079-89
8-719-079-89
8-719-079-89
25V
25V
16V
25V
25V
R816
R817
R818
R819
R820
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
820
820
820
820
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R821
R822
R823
R824
R825
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
820
820
820
820
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R826
R827
R828
R829
R830
1-216-839-11
1-216-833-11
1-216-829-11
1-216-821-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
10K
4.7K
1K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R831
R832
R833
R834
R835
1-216-825-11
1-216-819-11
1-216-817-11
1-216-815-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
680
470
330
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S811
S812
S813
S814
S815
1-771-884-11
1-771-884-11
1-771-884-11
1-771-884-11
1-771-884-11
SWITCH, TACTILE (WITH LED) (DISC1)
SWITCH, TACTILE (WITH LED) (A (DISC1))
SWITCH, TACTILE (WITH LED) (A (DISC2))
135
HCD-C770/C990
KEY
Ref. No.
MODE MOTOR
Part No.
POWER
Description
Remark
S816
1-771-884-11 SWITCH, TACTILE (WITH LED) (A (DISC3))
S817
1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC4)
S818
S819
1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC5)
S820
**************************************************************
MODE MOTOR BOARD
*******************
Ref. No.
Part No.
Description
C931
C932
C933
C934
1-165-723-21
1-115-339-11
1-165-723-21
1-115-339-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
1000uF
0.1uF
1000uF
0.1uF
Remark
C935
C936
C937
0 C938
0 C939
1-128-950-21
1-115-339-11
1-165-176-11
1-162-964-11
1-113-907-51
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
1000uF
0.1uF
0.047uF
0.001uF
0.0022uF
10%
10%
10%
20%
47uF
4.7uF
0.1uF
20%
20%
10%
10%
50V
10%
50V
16V
50V
16V
50V
250V
(AEP, AUS)
**************************************************************
A-4729-053-A POWER BOARD, COMPLETE (C990)
A-4730-639-A POWER BOARD, COMPLETE (AEP, AUS)
A-4676-957-A POWER BOARD, COMPLETE (C770: US, CND)
***********************
C941
C942
C946
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
1-506-996-11 PIN, CONNECTOR (PC BOARD) 14P
1-565-731-11 PLUG, CONNECTOR (2.5mm) 5P
< DIODE >
< CAPACITOR >
0 C901
0 C902
0 C903
0 C904
0 C905
1-126-163-11
1-104-705-11
1-104-705-11
1-162-960-11
1-162-968-11
ELECT
MYLAR
MYLAR
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.1uF
0.1uF
220PF
0.0047uF
20%
20%
20%
10%
10%
0 C909
0 C910
0 C911
0 C912
1-113-920-11
1-113-920-11
1-113-920-11
1-100-192-11
CERAMIC
CERAMIC
CERAMIC
ELECT
0.0022uF
0.0022uF
0.0022uF
1000uF
20%
20%
20%
20%
0 C912
1-165-911-21 ELECT
390uF
50V
250V
250V
50V
50V
250V
250V
250V
200V
(US, CND)
20%
450V
(AEP, AUS)
0 C913
0 C914
C915
0 C916
1-136-203-11
1-126-967-11
1-115-339-11
1-117-824-11
0 C916
1-104-332-11 FILM
470PF
C917
C918
0 C919
1-113-907-51 CERAMIC
0.0022uF 20%
0.1uF
10%
470PF
5%
0 C919
0.001uF
C920
1-137-699-11 FILM
2700PF
C920
1-117-454-11 FILM
4700PF
5%
C921
C922
C923
C924
1-115-819-11
1-162-964-11
1-115-819-11
1-126-953-11
ELECT
CERAMIC CHIP
ELECT
ELECT
2200uF
0.001uF
2200uF
2200uF
20%
10%
20%
20%
C925
C926
C927
C928
C929
1-126-947-11
1-162-927-11
1-115-339-11
1-126-953-11
1-124-584-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
47uF
100PF
0.1uF
2200uF
100uF
20%
5%
10%
20%
20%
16V
50V
50V
35V
10V
C930
0.1uF
10%
50V
136
FILM
ELECT
CERAMIC CHIP
FILM
16V
50V
50V
< CONNECTOR >
CN902
* CN903
CN904
1-533-313-11 HOLDER, FUSE
7-685-548-14 SCREW +BTP 3X12 TYPE2 N-S
1-126-947-11 ELECT
1-126-963-11 ELECT
10000PF
47uF
0.1uF
2200PF
5%
20%
10%
3%
630V
50V
50V
1.5KV
(US, CND)
10%
2KV
(AEP, AUS)
250V
50V
50V
(US, CND)
10%
50V
(AEP, AUS)
5%
630V
(US, CND)
630V
(AEP, AUS)
35V
50V
35V
35V
0 D902
0 D902
D904
0 D905
0 D906
8-719-022-92
8-719-312-05
8-719-109-97
8-719-200-91
8-719-200-91
DIODE
DIODE
DIODE
DIODE
DIODE
RBV-604 (US, CND)
RBV-606 (AEP, AUS)
MTZJ-T-77-6.8B
11EQS10-TA1
11EQS10-TA1
0 D907
0 D908
D911
D912
D913
8-719-200-91
6-500-241-01
8-719-313-14
8-719-109-93
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
11EQS10-TA1
SARS03
FML-22S
RD6.2ESB2
MA111-TX
D914
D915
D916
D917
0 D919
8-719-312-08
8-719-200-82
8-719-312-08
8-719-200-82
8-719-084-21
DIODE
DIODE
DIODE
DIODE
DIODE
FMB-G16L
11ES2
FMB-G16L
11ES2-NTA1B
10E6N-TA1B2
0 D920
D921
0 D931
0 D932
0 D933
8-719-084-21
8-719-210-21
8-719-110-53
8-719-924-13
8-719-200-91
DIODE
DIODE
DIODE
DIODE
DIODE
10E6N-TA1B2
11EQS04-TA1B
MTZJ-T-77-20B
MTZJ-T-77-22B
11EQS10-TA1
D990
8-719-404-50 DIODE MA111-TX
< GROUND TERMINAL >
EB901
EB902
1-537-770-21 TERMINAL BOARD, GROUND
1-537-770-21 TERMINAL BOARD, GROUND
< IC >
0 IC901
0 IC901
IC902
IC903
IC904
6-702-338-01
6-702-385-01
6-700-388-01
8-759-474-09
8-759-332-29
IC
IC
IC
IC
IC
STR-F6238 (US, CND)
STR-F6267S (AEP, AUS)
SE-B2
SI-8050S-LF1101
M51945BL
IC905
IC906
IC908
IC909
IC909
8-759-450-47
6-700-813-01
6-701-021-01
8-759-510-71
8-759-970-89
IC
IC
IC
IC
IC
BA05T
SI-8033JF
SI-8120JF
BA10358F-E2 (US, CND)
BA10358F-T1 (AEP, AUS)
sécurité.
HCD-C770/C990
POWER
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
POWER LED
Description
Remark
< COIL >
L901
L902
L903
L904
L905
1-424-860-11
1-456-183-11
1-456-182-11
1-414-398-11
1-414-398-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
150uH
100uH
10uH
10uH
L906
L907
L908
L909
L910
1-414-398-11
1-414-398-11
1-414-398-11
1-419-253-11
1-414-398-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
10uH
10uH
100uH
10uH
L911
1-414-398-11 INDUCTOR
1-456-081-11
1-456-082-11
1-456-081-11
1-456-082-11
FILTER, LINE (AEP, AUS)
FILTER, LINE (US, CND)
FILTER, LINE (AEP, AUS)
FILTER, LINE (US, CND)
< IC >
0 PC901
1-216-826-11 METAL CHIP
1-216-812-11 METAL CHIP
1-216-820-11 METAL CHIP
2.7K
180
820
5%
5%
5%
1/10W
1/10W
1/10W
(AEP, AUS)
1/10W
(US, CND)
1/10W
R916
1-216-822-11 METAL CHIP
1.2K
5%
R917
1-216-826-11 METAL CHIP
2.7K
5%
R918
R919
R920
R921
R922
1-216-826-11
1-216-835-11
1-216-809-11
1-216-837-11
1-218-866-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.7K
15K
100
22K
6.2K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R923
R924
R925
R926
R927
1-216-833-11
1-216-818-11
1-216-812-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
560
180
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R928
R929
0 R930
1-216-833-11 METAL CHIP
1-216-797-11 METAL CHIP
1-219-237-11 SOLID
10K
10
3.3M
5%
5%
20%
R931
R932
1-216-826-11 METAL CHIP
1-216-833-11 METAL CHIP
2.7K
10K
5%
5%
1/10W
1/10W
1/2W
(AEP, AUS)
1/10W
1/10W
1-216-833-11 METAL CHIP
1-215-904-11 METAL OXIDE
10K
100K
5%
5%
R935
R936
R937
1-216-845-11 METAL CHIP
1-216-847-11 METAL CHIP
1-216-821-11 METAL CHIP
100K
150K
1K
5%
5%
5%
1/10W
2W
(AEP, AUS)
1/10W
1/10W
1/10W
10uH
< LINE FILTER >
0 LF901
0 LF901
0 LF902
0 LF902
R914
R915
R916
8-749-019-04 IC TLP421
< TRANSISTOR >
R933
0 R934
Q901
Q902
Q903
Q904
0 Q905
8-729-900-53
8-729-900-53
8-729-900-53
8-729-901-81
8-729-111-29
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
2SC2412K-T-146-R
2SD1616A-TP-LK
Q906
Q910
Q911
Q912
Q914
8-729-900-53
8-729-900-53
8-729-900-53
8-729-901-81
8-729-901-81
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
2SC2412K-T-146-R
2SC2412K-T-146-R
R938
R939
R940
R941
R942
1-216-065-00
1-216-049-11
1-216-077-00
1-216-833-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
15K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q990
Q991
Q992
2SB1640 (TP)
2SC2412K-T-146-R
2SC2412K-T-146-R
R943
1-216-824-11 METAL CHIP
1.8K
5%
1/10W
< TRANSFORMER >
0 T901
0 T901
< RESISTOR >
0 R900
1-219-237-11 SOLID
3.3M
20%
0 R901
0 R902
1-216-813-11 METAL CHIP
220
0.15
5%
5%
0 R903
0 R904
0.15
0.22
5%
5%
0 R905
33K
5%
0 R905
68K
5%
R906
0 R907
0 R908
1-216-833-11 METAL CHIP
1-216-829-11 METAL CHIP
10K
4.7K
68K
5%
5%
5%
0 R909
R910
0 R911
0 R912
0 R913
1-215-902-11
1-216-829-11
1-216-828-11
1-216-823-11
1-249-385-11
METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
47K
4.7K
3.9K
1.5K
2.2
5%
5%
5%
5%
5%
1/2W
(US, CND)
1/10W
1W
(US, CND)
1W
1W
3W
(US, CND)
3W
(AEP, AUS)
1/10W
1/10W
3W
(AEP, AUS)
1-437-865-11 TRANSFORMER, POWER (US, CND)
1-437-866-11 TRANSFORMER, POWER (AEP, AUS)
< THERMISTOR >
0 TH901 1-803-916-11 THERMISTOR, NTC
**************************************************************
POWER LED BOARD
*****************
< LED >
D812
8-719-074-42 LED SLR325VR-T31 (STANDBY)
< RESISTOR >
R804
1-216-817-11 METAL CHIP
470
5%
1/10W
**************************************************************
2W
1/10W
1/10W
1/10W
1/6W
sécurité.
137
HCD-C770/C990
POWER S/W
Ref. No.
Part No.
RELAY
RF
Description
Remark
Ref. No.
Part No.
< CAPACITOR >
0 C900
1-165-528-11 MYLAR
0.1uF
Description
Remark
< RESISTOR >
POWER S/W BOARD
*****************
10
275V
R701
R702
R711
R712
R721
1-249-415-11
1-247-807-31
1-249-415-11
1-247-807-31
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
100
680
100
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< CONNECTOR >
* CN900
* CN901
< SWITCH >
R722
1-247-807-31 CARBON
100
5%
1/4W
R731
1-249-407-11 CARBON
150
5%
1/4W
R732
1-249-417-11 CARBON
1K
5%
1/4W
R733
1-249-429-11 CARBON
10K
5%
1/4W
R734
1-249-431-11 CARBON
15K
5%
1/4W
**************************************************************
0 S901
1-786-377-11 SWITCH, POWER (POWER)
**************************************************************
A-4728-690-A RF BOARD, COMPLETE
*******************
A-4728-700-A RELAY BOARD, COMPLETE
**********************
< CAPACITOR >
< CAPACITOR >
C711
C751
C752
C753
C754
1-126-795-11
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
C755
C756
C758
C761
C762
1-164-159-21
1-164-159-21
1-164-159-21
1-162-306-11
1-164-159-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.1uF
0.01uF
0.1uF
C763
C764
C765
C766
C767
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
50V
50V
50V
50V
50V
C768
C769
C771
C781
1-164-159-21
1-164-159-21
1-162-306-11
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.01uF
0.01uF
50V
50V
16V
16V
30%
30%
30%
50V
50V
50V
50V
50V
50V
50V
50V
16V
50V
< CONNECTOR >
CN701
CN702
CN703
CN704
CN710
1-779-565-21
1-785-329-11
1-785-328-11
1-785-328-21
1-568-945-11
PIN, CONNECTOR (LIGHT ANGLE) 3P
PIN, CONNECTOR (LIGHT ANGRE) 2P
PIN, CONNECTOR (LIGHT ANGRE) 2P
PIN, CONNECTOR 7P
< DIODE >
D701
D711
D721
8-719-921-40 DIODE MTZJ-T-77-4.7B
8-719-921-42 DIODE MTZJ-T-77-5.1A
8-719-982-03 DIODE MTZJ-T-77-3.6A
< IC >
IC701
IC711
IC721
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q731
138
C001
C002
C003
C004
C005
1-126-206-11
1-124-779-00
1-126-206-11
1-124-779-00
1-128-993-21
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
100uF
10uF
100uF
10uF
22uF
20%
20%
20%
20%
20%
6.3V
16V
6.3V
16V
10V
C006
C008
C009
C010
C011
1-128-993-21
1-107-826-11
1-107-826-11
1-115-416-11
1-115-416-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.1uF
0.1uF
0.001uF
0.001uF
20%
10%
10%
5%
5%
10V
16V
16V
25V
25V
C012
C013
C014
C015
C016
1-107-826-11
1-107-826-11
1-162-966-11
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.0022uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
16V
16V
50V
50V
50V
C017
C018
C019
C020
C021
1-162-966-11
1-164-172-11
1-164-172-11
1-162-919-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.0056uF
0.0056uF
22PF
22PF
10%
10%
10%
5%
5%
50V
25V
25V
50V
50V
C022
C023
C024
C025
C026
1-162-919-11
1-162-919-11
1-162-970-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
0.01uF
0.1uF
0.1uF
5%
5%
10%
10%
10%
50V
50V
25V
16V
16V
C027
C028
C029
C030
C031
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
1-115-416-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
0.01uF
0.001uF
10%
10%
10%
10%
5%
16V
16V
25V
25V
25V
C032
C033
C034
C035
C036
1-165-176-11
1-107-826-11
1-107-826-11
1-107-826-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.1uF
0.1uF
0.1uF
0.47uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
10V
C037
C038
C039
C040
C041
1-162-959-11
1-164-677-11
1-164-677-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
0.033uF
0.033uF
0.1uF
0.1uF
5%
10%
10%
10%
10%
50V
16V
16V
16V
16V
C042
180PF
0.25PF 50V
RT1N141S-TP
sécurité.
RF
ROLLER MOTOR
SEL
STOCKER MOTOR
Ref. No.
C049
Part No.
Description
Remark
0.1uF
10%
SW (1)
Ref. No.
Part No.
SW (2)
HCD-C770/C990
SW (3)
Description
SW (4)
Remark
16V
ROLLER MOTOR BOARD
********************
< CONNECTOR >
CN001
CN002
CN003
SENSOR
1-815-031-11 CONNECTOR, FFC/FPC (ZIF) 24P
**************************************************************
SEL BOARD
**********
< DIODE >
D001
D002
S826
1-771-692-11 SWITCH, SLIDE (SCAN SELECT)
**************************************************************
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
1-685-004-11 SENSOR BOARD
**************
< IC >
IC001
< PHOTO SENSOR >
8-752-417-53 IC CXD1881AR
IC751
8-749-017-45 SENSOR, PHOTO RPR-220C1N
(DISC INSERT DETECT SENSOR)
**************************************************************
< COIL >
L001
L002
1-412-031-11 INDUCTOR CHIP 47uH
1-412-031-11 INDUCTOR CHIP 47uH
1-685-006-11 STOCKER MOTOR BOARD
*********************
< TRANSISTOR >
Q001
Q002
2SB1132-T100-QR
2SB1132-T100-QR
**************************************************************
1-685-008-11 SW (1) BOARD
************
< RESISTOR >
R001
R003
R004
R005
R006
1-218-668-11
1-216-803-11
1-216-803-11
1-216-841-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
33
33
47K
470
0.5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R007
R008
R009
R010
R011
1-216-803-11
1-216-803-11
1-216-841-11
1-216-817-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33
33
47K
470
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R012
R013
R014
R015
R016
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R017
R018
R019
R020
R021
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R022
R023
R024
R025
R026
1-216-813-11
1-216-820-11
1-216-864-11
1-216-809-11
1-218-718-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
820
0
100
12K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/16W
R027
R028
R029
R032
R033
1-216-864-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
100
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S711
1-786-382-11 SWITCH, PUSH (1 KEY)
(DISC INSERT (8/12cm))
**************************************************************
1-685-009-11 SW (2) BOARD
************
< SWITCH >
S713
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC IN (8/12cm))
S714
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC IN (8cm))
**************************************************************
1-685-010-11 SW (3) BOARD
************
< SWITCH >
S715
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC OUT)
**************************************************************
1-685-011-11 SW (4) BOARD
************
< SWITCH >
S716
1-786-382-11 SWITCH, PUSH (1 KEY) (STOCKER IN/OUT)
S717
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC POSITION)
S718
1-786-382-11 SWITCH, PUSH (1 KEY) (STOCKING)
**************************************************************
R034
1-219-570-11 RES-CHIP
10M
5%
1/10W
R035
1-216-864-11 METAL CHIP
0
5%
1/10W
R041
1-216-821-11 METAL CHIP
1K
5%
1/10W
**************************************************************
139
HCD-C770/C990
VIDEO
Ref. No.
VOL
Part No.
Description
Remark
A-4728-874-A VIDEO BOARD, COMPLETE
**********************
Ref. No.
IC208
IC209
Part No.
< CAPACITOR >
Remark
< TERMINAL BOARD >
C202
C218
C248
C252
C265
1-126-369-11
1-124-589-11
1-126-153-11
1-164-156-11
1-126-157-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
220uF
47uF
22uF
0.1uF
10uF
20%
20%
20%
C267
C272
C274
C275
C276
1-124-584-00
1-164-156-11
1-126-157-11
1-164-156-11
1-126-157-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100uF
0.1uF
10uF
0.1uF
10uF
20%
C277
C278
C279
C280
C281
1-126-153-11
1-126-157-11
1-162-974-11
1-126-160-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
22uF
10uF
0.01uF
1uF
0.1uF
20%
20%
C282
C283
C284
C285
C286
1-164-156-11
1-126-160-11
1-124-584-00
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
1uF
100uF
0.1uF
0.1uF
C287
C288
C289
C290
C291
1-164-156-11
1-164-156-11
1-126-157-11
1-164-156-11
1-126-157-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.1uF
0.1uF
10uF
0.1uF
10uF
C292
C293
C294
C295
C296
1-126-369-11
1-124-584-11
1-164-156-11
1-124-584-00
1-126-518-11
ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT
220uF
100uF
0.1uF
100uF
470uF
20%
20%
6.3V
10V
25V
10V
4V
C297
C298
C299
C300
C301
1-126-369-11
1-124-584-11
1-126-153-11
1-124-584-00
1-126-153-11
ELECT
ELECT
ELECT
ELECT
ELECT
220uF
100uF
22uF
100uF
22uF
20%
20%
20%
20%
20%
6.3V
10V
6.3V
10V
6.3V
C302
1-124-584-00 ELECT
100uF
20%
10V
20%
20%
20%
20%
20%
20%
20%
20%
20%
20%
6.3V
16V
6.3V
25V
16V
10V
25V
16V
25V
16V
6.3V
16V
50V
50V
25V
25V
50V
10V
25V
25V
25V
25V
16V
25V
16V
< CONNECTOR >
CN203
CN207
Description
6-702-335-01 IC MM1568
8-759-284-49 IC NJM2285V-TE2
J202
1-694-920-11 TERMINAL BOARD (MONITOR OUT)
< COIL >
L202
L207
L209
1-469-525-11 INDUCTOR
1-469-525-11 INDUCTOR
1-469-525-11 INDUCTOR
10uH
10uH
10uH
< TRANSISTOR >
Q210
Q214
DTA114EKA-T146
DTC144EKA-T146
< RESISTOR >
R256
R259
R265
R266
R267
1-216-833-11
1-218-285-11
1-216-833-11
1-216-833-11
1-218-285-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
10K
75
10K
10K
75
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R268
R269
R270
R273
R278
1-218-285-11
1-218-285-11
1-218-285-11
1-218-285-11
1-216-833-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
75
75
75
75
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R286
1-216-833-11 METAL CHIP
10K
5%
1/10W
**************************************************************
1-685-887-11 VOL BOARD
**********
< CAPACITOR >
C800
C801
0.01uF
0.01uF
10%
10%
25V
25V
< CONNECTOR >
* CN820
1-568-941-11 PIN, CONNECTOR 3P
< SWITCH >
S800
1-418-632-11 ENCODER, ROTARY (VOLUME)
**************************************************************
MISCELLANEOUS
**************
< FERRITE BEAD >
FB201
FB202
FB203
FB204
FB205
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
1-469-324-21
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0uH
0uH
0uH
0uH
0uH
FB206
1-469-324-21 FERRITE
0uH
< IC >
IC204
IC206
IC207
140
6-600-013-01 IC TORX179L (OPTICAL DIGITAL IN VIDEO2)
6-702-334-01 IC MM1510
8-759-696-10 IC NJM2235V (TE2)
104
110
201
202
204
1-824-479-11
1-824-478-11
1-824-626-11
1-824-483-11
1-824-478-11
205
206
207
208
209
1-824-625-11
1-500-657-11
1-824-480-11
1-824-481-11
1-824-482-11
CORE, FERRITE
212
252
1-469-854-11 CORE FERRITE
sécurité.
HCD-C770/C990
Ref. No.
Part No.
0 253
0 253
0 253
1-783-531-72 CORD, POWER (US, CND)
1-696-169-12 CORD, POWER (AEP)
1-696-848-42 CORD, POWER (AUS)
257
258
258
0 603
605
0 F901
Description
Remark
Part No.
Description
Remark
(AEP, AUS)
(US, CND)
1-477-263-11 PICKUP UNIT (TDP022W)
1-685-250-11 FLEXIBLE BOARD
FL801
M301
M761
(US, CND)
(AEP, AUS)
1-518-824-11 INDICATOR TUBE, FLUORESCENT
1-763-861-11 FAN, DC
A-4735-953-A MOTOR (STOCKER) ASSY (MODE)
M771
M781
S702
S771
A-4735-953-A
A-4735-953-A
1-477-299-11
1-477-300-11
0 F901
Ref. No.
MOTOR (STOCKER) ASSY (ROLLER)
MOTOR (STOCKER) ASSY (STOCKER)
ENCODER, ROTARY (STOCKER POSITION)
ENCODER, ROTARY (MODE)
sécurité.
141
HCD-C770/C990
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
1.1
Date
2002.07
2002.10
1.2
2002.12
1.3
2003.01
1.4
2003.03
1.5
2003.07
Description of Revision
New
Addition of “RELEASING THE DISC SLOT LOCK” to the SERVICING NOTES
(SPM-02096)
Correction of Part No. for EXTENSION CABLE (DVD board – AMP
board)
(SPM-02112)
Addition of “CHECKING OF OPERATIONS WITH REMOTE
COMMANDERS OF DIFFERENT MODELS” to the SERVICING
NOTES
(SPM-02118)
Addition of “TEST DISC LIST” to the TEST MODE
Addition of “AUTO SERVO ADJUSTMENT” to the ELECTRICAL
ADJUSTMENT
(SPM-03008)
Correction of ASSEMBLY
Addition of “PHASE ADJUSTMENT BETWEEN PINIONS (SLIDER)
AND SLIDER-1 TO 5 (L/R)” to the ASSEMBLY
(SPM-03063)

DAV-C770 - Free Service Manuals

Transcription

Similar documents

SERVICE MANUAL

Pages 51-100 Catalog Volume 16

SERVICE MANUAL

service manual - Pagesperso

SERVICE MANUAL