Tacky mats

TACKY MATS
12.
12.11
IMPORTANT INFORMATION
ABOUT TACKY MATS
General Information
Tacky mats prevent the unintentional importation of large quantities of particles
into the cleanroom on the soles of people's shoes. The combination of a washable
permanent adhesive mat and a strongly adhesive peel off tacky mat offers the
optimum protection and reduces the running costs.
DASTMAT-100
permanently adhesive and washable
This mat is mainly used for the initial, intensive pre-cleaning of the contact
surface of the soles. Mostly it is used as first cleaning step before entering the
cleanroom. Based on the soft material consistency the sole can be reached in
places which are not covered when using the inflexible material of foil mats.
DASTMAT-30, and DASTMAT-60
peel off tacky mats
Strong adhesion and robust design make these mats ideal for the cleaning of
soles, castors, etc. inside the transfer area.
Frames and movable floor plates
The frame for the foil tacky mats is used both as edge protection and as a ramp.
The movable floor plate is designed for mobile applications of the foil tacky mats.
The DASTMAT-system
GREY AREA
TRANSFER AREA
DASTMAT-100
DASTMAT-30, -60
permanent adhesive
and washable
30 or respectively 60
peel off foils
CLEANROOM
Entrance direction
for “larger particles”
less adhesive strength
for “smaller particles”
more adhesive strength
For further information please contact us:
phone +49 (0)72 22-96 96-60 · fax +49 (0)72 22-96 96-88 · e-mail [email protected] · www.dastex.com
Version 07/ 2008
Whilst we take every care to ensure the accuracy of the information provided we can not take responsibility for errors introduced at the printing stage.
PERMANENT ADHESIVE
TACKY MATS
table of cleanroom classes
see chapter 12.6
Application areas
in front of the personnel transfer areas
in the dressing area
in front of and / or behind the "Sit-Over"
Properties
permanently adhesive and washable tacky mat
traps larger particles and prevents heavy loads of contamination entering the
clean zone / lock
the "pre-cleaning effect" of the DASTMAT-100 can reduce the usage of the
secondary laid foil tacky mat – and with it the running costs
the saturated DASTMAT-100 can simply be cleaned with warm water
As soon as the mat is dry again it regains its adhesive properties
No solvent based cleaning agents should be used as these will destroy the
adhesive properties of the mat
because of the weight of the mat, the consistency of the material and the low
height the mat can simply be laid as a non-slip mat – without frame – on the
flat and cleaned floor. It should be remembered though, that the floor and the
mat must be completely dry in order to prevent the danger of skidding
Permanent adhesive tacky mats are available in two qualities:
DASTMAT-100, high value mats
Dimensions
Colour
Art.-No.
Standard
approx. 1200 x 600 x 2.3 mm
5020
Rolled goods1
width approx. 1200 mm
5023
blue
simple mats for an economical price
Dimensions
Colour
Art.-No.
Standard
approx. 1200 x 600 x 2.3 mm
5027
Standard2
approx. 1000 x 1000 x 3 mm
5028
blue
1
2
delivery from 1 m onwards
in rolls on request
For further information please contact us:
phone +49 (0)72 22-96 96-60 · fax +49 (0)72 22-96 96-88 · e-mail [email protected] · www.dastex.com
Version 07/ 2008
Whilst we take every care to ensure the accuracy of the information provided we can not take responsibility for errors introduced at the printing stage.
TACKY MATS
12.
12.22
PEEL OFF TACKY MATS
table of cleanroom classes
see chapter 12.6
Application areas
directly before or behind the inner transfer door
during maintenance
DASTMAT-30
Properties
30 layers of peel off tacky mat (30 single layers self-adhesive PE foil)
clearly higher adhesion than DASTMAT-100 to trap smallest particles
self-adhesive underneath for good grip on the floor
when the top layer of the tacky mat is saturated it is torn off to reveal the next
adhesive layer beneath
there is a reverse index numbering on the single layers to show clearly time
the remaining number of sheets
total height only 2.0 mm for 30 layers on average
Microbiocide treated mats are available on request (compare chapter 12.5)
DASTMAT-60
Properties
60 layers of peel off tacky mat (60 single layers self-adhesive PE foil)
total height only 2.3 mm for 60 layers on average
The financial advantages are as follows:
- reduction of storage costs.
- reduction of ordering frequency
- because of the double quantity of foils the timely work cost of changing mats
is reduced
the mat is available with a microbiocide on request (compare chapter 12.5)
as details as DASTMAT-30
Article
Dimensions
Colour
PU
Art.-No.
DASTMAT-30 1140 x 660 x 2 mm
/
4 mats / case
5030*
DASTMAT-30 1140 x 660 x 2 mm
/
8 mats / case
50311
DASTMAT-30 1140 x 460 x 2 mm
/
4 mats / case
5040*
DASTMAT-30 1140 x 460 x 2 mm
/
8 mats / case
50411
DASTMAT-60 1140 x 660 x 2.3 mm
/
4 mats / case
5060*
DASTMAT-60 1140 x 660 x 2.3 mm
/
4 mats / case
5070*
/ transparent
blue
* mat equipped with microbiocide
Additional colours and sizes are available on request.
For further information please contact us:
phone +49 (0)72 22-96 96-60 · fax +49 (0)72 22-96 96-88 · e-mail [email protected] · www.dastex.com
Version 07/ 2008
Whilst we take every care to ensure the accuracy of the information provided we can not take responsibility for errors introduced at the printing stage.
TACKY MATS
12.
12.33
FRAMES FOR TACKY MATS
table of cleanroom classes
see chapter 12.6
Those frames are used both as edge protection and a ramp. Often they are also
chosen for decorative reasons.
As with the foil mats, the frames can also be tightly stuck down to the floor.
The frames are equipped with a special non slip cover allowing a flexible use.
Dimensions
Material
PU
Art.-No.
1140 x 660 mm
aluminium
1 piece per case
5039
1140 x 460 mm
aluminium
1 piece per case
5049
FLOOR PLATES FOR TACKY MATS
Sometimes the peel-off mats have to be removed from the floor before all layers
have been used. For these occasions we offer "movable" floor plates. The foil mats
are not adhered anymore directly onto the floor, but on the upper side of these
special floor plates.
This frame is equipped with a special new slip cover preventing the mat from slipping.
If, for example, the floor has to be cleaned daily, the floor plate is simply removed
together with the mat.
After having cleaned the floor – and after ensuring that the floor is completely dry
– the floor plate including the foil mat can be reinstalled on the chosen place.
Dimensions
Material
PU
Art.-No.
1140 x 660 mm
plastic
1 piece per case
5058
1140 x 460 mm
plastic
1 piece per case
5068
For further information please contact us:
phone +49 (0)72 22-96 96-60 · fax +49 (0)72 22-96 96-88 · e-mail [email protected] · www.dastex.com
Version 07/ 2008
Whilst we take every care to ensure the accuracy of the information provided we can not take responsibility for errors introduced at the printing stage.
TACKY MATS
12.
12.44
FOIL MATS WITH MICROBIOCIDE
Additional information for microbiological controlled areas
When walking or pushing a trolley over tacky mats there are not only dust particles sticking to the mat,
but also bacteria and fungi. Therefore a biocide has been added to the adhesive foil of our tacky mats,
preventing growth of known bacteria and fungi.
Below is a list of organisms against which the micro biocide is effective. This information has been
provided by the manufacturer for which we cannot take any responsibility. Mats equipped with micro
biocide see chapter 12.3.
BACTERIA (GRAM-NEGATIVE)
FUNGI
Achromobacter parvulus
Aspergillus foetidus
Alcaligenes faecalis
Aspergillus niger
Azotobacter vinelandil
Aspergillus oryzae
Enterobacter aerogenes
Aureobasidium pullulans
Escherichia coli
Candida albicans (yeast plant)
Flavobacterium suaveolens
Chaetomium globosum
Nitrobacter agilis
Cladosporium resinae
Proteus vulgaris
Gliocladium fimbriatum
Pseudomonas aeruginosa
Lentinus lepideus
Pseudomonas cepacia
Lenzites trabea
Pseudomonas fluorescens
Mucor rouxil
Pseudomonas oleoverans
Penicillium funiculosum
Salmonella typhosa
Penicillium variabile (glaucum)
Shigella sonnel
Phoma herbarum (pigmentivora)
Rhizopus stolonifer
BACTERIA (GRAM-POSITIVE)
Bacillus cereus var. mycoides
Bacillus subtilis
Rhototorula rubra (yeast plant)
Saccharomyces cerevisiae (yeast plant)
Trichophyton mentagrophytes (interdigitale)
Brevibacterium ammoniagenes
Cellulomonas sp.
Sarcina lutea
Staphylococcus aureus
Staphylococcus epidermidis
Streptococcus pyogenes
Streptomyces albus
For further information please contact us:
phone +49 (0)72 22-96 96-60 · fax +49 (0)72 22-96 96-88 · e-mail [email protected] · www.dastex.com
Version 07/ 2008
Whilst we take every care to ensure the accuracy of the information provided we can not take responsibility for errors introduced at the printing stage.
TACKY MATS
12.
12.55