Skid Loader - Hawkins Equipment

Transcription

Form No.
902407
J
I
W
SERVICE PARTS MANUAL l!I
2
_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ HL2800 - INTRODUCTION Mr. Operator:
Your decision to purchase Gehl equipment is a wise one.
You have made a sound and lasting investment. Gehl
Company has been building quality equipment for well
over a century. Our entire manufacturing and marketing
philosophy is built upon quality. The quality built into
Gehl products assure you the performance and reliability
you need to make a profit. Your authorized Gehl Skid
Steer Loader dealer is equipped to service your Gehl
equipment. They maintain genuine Gehl service parts.
This manual was written for the operator so that he can
find the information which he needs to know to correctly
prepare, adjust, service and understand this unit.
The operator should read this manual thoroughly so that
the important facts about this unit and the contents of the
manual are known . The safety of the operator and the
reliability and performance of this unit will be determin
ed by the knowledge of the contents of this manual.
Each section of this manual is clearly identified and is
divided into smaller sections. The Table of Contents and
Index can be used to find the information that is needed.
All service parts should be obtained from or ordered
through ·your Gehl dealer. Give complete information
when ordering service parts. The model number and
serial number should always be given. Record numbers in
the space provided as a handy record for quick reference.
Numbers for this unit are stamped on a plate which is
located on the right front surface of the Frame Cross
Member.
Gehl Company reserves the right to make changes or
improvements in the design or construction of any part
without incurring the obligation to install such changes
on any unit previously delivered.
"Right" and "Left" are determined from a position sitting
on the seat and looking forward . From this position, the
Traction T-bar is the left-hand Control and the Lift / Tilt
T-bar is the right-hand Control.
•
IMPORTANT HARDWARE NOTICE
All Cap Screws or Bolts called-out in the Parts Lists are
Grade 5 cadmium plated unless otherwise specified.
Hexagon Nuts for Grade 5 Cap Screws or Bolts are
Grade "B". Hexagon Nuts for other Cap Screws or Bolts
are Grade "A" unless otherwise specified.
The following abbreviations are used in the Parts Lists:
HHCS
SHCS
SHSS
- Hexagon Head Cap Screw
- Socket Head Cap Screw
- Socket Head Set Screw
HN
HJN
HLN
SN
WN
-
PW
LW
HLW
- Plain Washer
- Lock Washer
- Hexagon Lock Washer
L.H.
NF
- Left-Hand Thread
- National Fine Thread
Hexagon Nut
Hexagon Jam Nut
Hexagon Lock Nut
Slotted Nut
Wing Nut
TABLE OF CONTENTS
Page
Introduction ................................... 3
Decal Location ............................... 4-5
Main Frame ................................. 6-7
Engine ...................................... 8-9
Axle and Drive ............................. 10-11
Reversing Drive ............................... 12
Console and Controls .......................... 13
Transmission . . ................................ 14
Load Arm .................................... 15
Hydraulics ................................. 16-17
Mechanical Brake .............................. 18
Electrical System .............................. 19
Lift and Tilt Drive ............................. 20
Gear Pump ................................... 21
Hydraulic Cylinders ......................... 22-23
Page Hydrostatic Transmission ....................... 24 Accessories ................................. 26-30 Utility Bucket - 50" Wide ....•................ 26 Utility Bucket - 54" Wide ..................... 26 Light Material Bucket ........................ 26 Fertilizer Bucket ............................. 26 Produce Bucket .............................. 26 Manure Fork ................................ 27 Pallet Fork ................................. 27 Drawbar .................................... 27 Bucket Tooth ............................... 27 Grapple Fork ............................... 28 Light Kit .................................. . 29 Front Hydraulics Kit ......................... 30 Numerical Index ............................ 31-33 3
HL2800 - DECAL LOCATION
Decal Locations are shown to assist in application of new
decals in the event of damage to the Decal or refinishing
of the machine. Check listing for information and the
illustrations for their location.
Surfaces MUST be free from dirt, dust, grease and other
foreign material before applying the new Decal. To
apply, remove the smaller portion of the decal backing
paper and apply this part of the exposed adhesive
backing to the clean surface while maintaining proper
position and alignment. Peel the other portion of the
backing paper off slowly while applying hand pressure to
smooth out Decal surface .
NOTE: Always order Decals by set number.
•
DO N OT order Decals separately.
A
WARNI NG: ALWAYS o bserve Safety Rules
shown on the Decals. If Decals become
damaged, or if unit is repainted, repl ace
Decals.
NOTI CE
Order paint for refinishing mach ines from th is
list:
901225
901226
610239
610240
I
One Gallon Blaze Paint
One Gallon Ma ize Paint
6 (12 oz.) Cans Blaze Spray Paint
6 (12 oz.) Cans Maize Spray Paint
The Decal Set Number for the HL2800 is0689l8 . Theset
includes the following:
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
-
057008
061187
061201
065988
068425
068487
061312
061268
060144
061310
061328
061327
068483
063435
067518
067914
17 - 063074
18 - 061313
19 - 068320
20 21 - 055635
22 - 055634
23 - 054953
24 - 068434
25 - 061311
4
Decal - Diesel Fuel
Decal - Grease Fitting (Two Places)
GEHL 3" x 16" (Two Places)
2800 (Two Places)
Decal - WAR NING (Two Places)
Decal - Ca rry Load Low
WARNI NG - Lift Arm Lock
WARNING - Electrical
WARNING - Read Operator's Manual
WARNING - Fasten Seat Belt
WARNING - DO NOT ENTER
Decal - Slow-Fast (Turtle-Rabbit)
Decal - Brake
Decal - T -bar Control Operation
Decal - Instrument Panel
Decal - Hydraulic Oil Filter Indicator
Decal - Bucket Densities
WARNI NG - General
GEHL 3" x 17"
Decal - Cooling System NOT Replaceable Decal - Coolant Under Pressure Symbol Decal - Engine Oil Symbol (Two Places) Decal - Hyd raulic Oil WARNING - Replace Guard (Six Places) - Four NOT Shown WARNING - Carry Load Low 19
5. 6.7 .8.12.13.14 .15,16.17.1 8,24, 25
~20 34
22
(
r
1 23
2~ 5,1
24
3
10,
4
11
5
~.
:
2:=;fi~~----:
~
~-::::;;;:;:=::;;=
HL2800 - D
E9AL LOCATION
•
\.JD
~/
5
36 6
46
18
~
49
'.
33
~
49
43
IMPORTANT: Order by Part Number - DO NOT use Illustration Reference Numbers. ~'
', ,
~14
?
16
15
ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS
6
HL2800 - MAIN FRAME Ref.
No.
Part
No.
Part Name
No.
Req.
I 9H300
Lock Pin ..... . ................ 2
2 047269
Mounting Socket .... . .......... I
650687
CB 5fl6 x 3/4 ............... 2
(2) 5/ 16 HLN 650804
3 054846
Male Pipe Coupling ... . ........ 2
4 055021
Hose Clamp ............ . ...... I
(I) 5/16 PW 654004
5 061520
Gas Filler Cap ................. 1
6 061859
Seat ......... .. ............... I
650486
HHCS 5fl6 x 3/4 ............ 4
(4) 5/16 LW 654024
7 062013
Filler Pipe ..................... I
8 062016
Filler Pipe Hose ........... . .... I
9 062017
Hose Clamp ........... .. ...... 2
10 062111
Pivot Linkage .................. I
650774
CB 1/ 2 x 2 .......... . ....... I
(I) 1/ 2 HJN 653044
I I 062118
Filler Cap/ Dipstick . .... . ... . ... I
12 062130
Control Valve Mount ........... 1
13 063436
Seat Reinforcement - Rear ... . .. . I
14 065906
Socket Pipe Plug ............... 4
15 067609
Main Frame ..... . ............. I
650733
HHCS 5jI6 x 1-1/2 ......... . 4
650547
HHCS 5fl6 x 3-1 / 2 .......... 6
650490
HHCS 3/8 x I ........... . ... 12
650491
HHCS 3/ 8 x 1-1/4 ........... 3
(8) 5/ 16 HLN 650804 - (2) 3/8 HLN 650805
(3) 3/8 LW 654026
650494
HHCS 1/2 x I ........ . ...... 2
(4) 1/ 2 PW 654009 - (16) 1/2 LW 654030
650495
HHCS 1/ 2 x 1-1 / 4 ........... 12
650558
HHCS 1/ 2 NF x 1-1 / 2 ........ 8
650653
HHCS 1/ 2 x 4-1 / 2 ........... 2
650424
HHCS 9/16 NF x 2 .. ........ 24
650694
HHCS 5/ 8 x 2-1/2 ........... 4
(4) 5/ 8 HN 653021 - (8) 5/ 8 PW 654012
(4) 5/8 LW 654032
650874
SQHSS 1/2 x 4 .............. 2
(2) 1/ 2 HJN 653044
16 067630
Flexible Trim ............. . .... I
17 067631
Fuel Tank ................. . ... 1
650490
HHCS 3/ 8 x I ............... 2
(2) 3/ 8 PW 654006 - (2) 3/ 8 L W 654026
18 067666
Side Shield - Right .............
19 067674
Air Cleaner Base ...............
650484
HHCS 5/16 x 1/ 2 ............ 4
(4) 5/ 16 HLN 650804 - (4) 5/ 16 PW 654004
20 067694
Voltage Regulator Mounting
Bracket ..................... I
650490
HHCS 3/8 x I . .............. 2
650542
HHCS 1/ 4 x 1/ 2 ............. 2
(2) 1/ 4 HLN 650803 - (2) 3/ 8 L W 654026
Ref.
No.
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
Part
No.
Part Name
No .
Reg.
067750
Speed Nut ..................... 2
Fuel Sender .................. . . 1
067780
067793
Seat Hinge ..............•..... I
650704
CB 3/8 x I ...... ............ 2
(2) 3/ 8 HLN 650805
067794
Seat Belt ...... .. .. . ...........
067798
Seat Bottom ...................
650545
HHCS 5fl6 x 1-1/4 . .........
(I) 5fl6 HLN 650804
067804
Tailgate ............. . .... . ....
(2) 1/ 2 HLN 650806
067819
Gate Pin - Rear ................ 2
067856
Overhead Guard . . ... . ... . ..... . 1
067875
Instrument Cover. .............. I
650469
PTHMS 1/ 4 x 3/4 . .. . ....... 4
(2) 1/ 4 HLN 650803 - (2) 1/ 4 PW 654002
067888
Grommet . .............. . . " ... 3
067979
Seat - Right Rear ...... . .. . ... . . I
650484
HHCS 5/16 x 1/ 2 ............ I
650486
HHCS 5/16 x 3/4 ............ 4
(5) 5/ 16 PW 654004 - (5) 5/ 16 LW 654024
Seat - Left Rear ..... . .... . .... . 1
067980
650486
HHCS 5/16 x 3/ 4 .... . . . .. . .. 2
(2) 5/16 PW 654004 - (2) 5/16 LW 654024
067981
Side Shield - Left ...............
Flywheel Guard ................
068035
(3) 3/ 8 HLN 650805 - (3) 3/ 8 PW 654006
068039
Guard Support ................. I
068647
Sound Liner .................. . 1
068648
Seat Bottom Foam ............. I
068649
Seat Back Foam - Right ........ . I
068650
Seat Back Foam - Left .......... I
068651
Window ... . ................... I
068652
Weather Strip - Top ............ 2
068653
Weather Strip - Side ......... . .. 2
068654
Barrier - Front Lower ........... 1
Barrier Support .. . .... . ..... . .. 2
068655
650486
HHCS 5/ 16 x 3/4 ............ 2
(2) 5/ 16 HLN 650804 - (2) 5/ 16 PW 654004
068656
Foam - Right ..... . .. . ......... I
068657
Foam - Left ................ . .. 1
068658
Seat Back Barrier ............... 1
650484
HHCS 5/16 x 1/ 2 ............ 5
(5) 5/16 PW 654004 - (5) 5fl6 LW 654024
068659
Tailgate Isolate . . .............. . 2
Trim (12") ..................... 2
068960
069296
Trim (4-1 / 2") .................. 1
660091
Pipe Coupling - 3/ 8 ............. 2
7
HL2800 - ENGINE IMPOR~TA~~~----~
NOT u se IlJustratio
NT: Order
y Part Numb
n Rbeference
N urn berers.
- DO
1
18
~-{ 1
~~
bt
d'
8
2~Ji
Il)~~,fj,.""""""
~20 24~~21
~
?~ ~
/@~ ~261
%: ~
28~
(L..14
23
"Z
4
17
. :
68
67 2
f/
33 23
" 22
•
10 61/
21
65
F-16
o
I
27
10
29
\
61
18
& 27
10~ 1lJt~
61::j
8
69
~30
_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ HL2800 - ENGINE Ref.
No.
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20 21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
Part
No.
Part Name
No.
Req.
054885
Ball Joint. . . . . . . . . . . . . . . . . . . . .. 2
(2) 1/ 4 NF HN 650546 - (2) 1/ 4 LW 654022
054959
Bellville Washer. . . . . . . .. . . . . . .. 2
055014
Air Cleaner. . . . . . . .. . . . . . . . . . . . I
Mounting Band...... .. ........ 2
055015
650486
HHCS 5/ 16 x 3/ 4 ....... . .... 4
(4) 5/ 16 HN 653007 - (4) 5/ 16 LW 654024
055016
Air Stack Cap.... ...... ... .... I
055018
Restriction Indicator. . . . . . . . . . . . I
055030
Hose Clamp. . . . . . . . . . . . . . . . . .. 4
055913
Temperature Sender Gauge.. .. . . I
056815
Oil Sender Gauge. . . . . . . . . . . . . . . I
060039
Isolation Mounting . . . . . . . . . . . .. 4
061166
Hose Clamp.... .... ........... 2
062019
U-Clamp ...................... 2
062023
Hose Clamp.. ............ ..... 2
062282
Vinyl Grip. . . . . . . . . . . . . . . . . . . . . I
064270
Muffler . ...................... I
065164
yoke...................... . ... I
065165
Clevis...... . ......... .. ....... I
650590
Cotter Pin 1/16 x 1/ 2 .. .. .. .. . I
065756
Washer. . . . . . . . . . . . . . . . . . . . . . .. 4
066574
Diesel Engine. . . . . . . . . . . . . . . . . . I
650542
HHCS 1/ 4 x 1/ 2 ............. 2
067638
Engine Mount - Right Front. . . . . I
650545
HHCS 5/16 x 1-1 / 4 .......... I
650495
HHCS 1/ 2 x 1-1 / 4 ........... 2
(2) 1/ 2 HLN 650806 - (I) 1/ 2 PW 654009
067642
Screw. . . . . . . . . . . . . . . . . . . . . . . . . 4
067643
Lock Washer. . . . . . . . . . . . . . . . .. 4
067644
Metric Hex. Nut. . . . . . . . . . . . . .. 4
067645
Engine Mount - Right Rear. . . . . . I
067648
Engine Mount - Left Rear . . . . . . . I
650773
CB 3/ 8 x 1-1 / 2............... 2
(2) 5/ 16 HLN 650804
067652
Metric Screw .. ............... . 4
067653
Metric Lock Washer. . . . . . . . . . .. 6
067654
Engine Mount - Left Front. . . . . . I
067658
Transmission Mount Plate. . . . . . . I
650495
HHCS 1/ 2 x 1-1 / 4 ........... I
FHCS 1/ 2 x I ............... I
650358
(I) 1/ 2 PW 654009 - (I) 1/ 2 LW 654030
067660
Metric Screw ......... . . . ...... 2
067661
Fuel Suction Line.............. I
067662
Fuel Return Line. . . . . . . . . . . . . . . I
067663
Throttle Rod . . . . . . . . . . . . . . . . . . . I
650590
Cotter Pin 1/ 16 x 1/ 2. . . . . . . .. 4
(2) 5/16 PW 654004
Throttle Link ............ .. ... .
067664
067665
Throttle Rod .. .. . ..... . ..... .. .
(2) 1/ 4 NF HN 650546
067667
Air Cleaner Hose. . . . . . . . . . . . . . . I
067668
Air Intake. . . . . . . . . . . . . . . . . . . .. I
067671
Air Intake Gasket. . . . . . . . . . . .. . I
067672
Metric Screw . . .............. .. 6
067673
Lock Washer. . . . . . . . . . . . . . . . . . 6
Ref.
No.
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
Part
No.
Part Name
No.
Req.
067676
Exhaust Pipe. . . . . . . . . . . . . . . . . .
067679
Exhaust Manifold Gasket. . . . . . . .
067681
Tail Pipe. . . . . . . . . . . . . . . . . . . . . .
067683
Radiator ......... . ... . ........
650486
HHCS 5/16 x 3/ 4 .... . .. .. .. .
(6) 5/16 PW 654004 650487
HHCS 5/16 x I ..............
067684
Radiator Pressure Cap. . . . . . . . . .
067685
Drain Cock. . . . . . . . . . . . . . . . . . . .
067686
Radiator Hose - Upper..........
067687
Radiator Hose - Lower. . . . . . . . . .
067688
Radiator Support - Front. . . . . . . .
067691
Radiator Support Angle. . .. .... .
650487
HHCS 5/16 x I ..............
(2) 5/16PW 654004 067692
Radiator Support - Rear Upper. .
650487
HHCS 5/16 x I ..............
650490
HHCS 3/ 8 x I .......... . .. . .
(2) 3/ 8 PW 654006 - (2) 3/ 8 L W 654026 067693
Radiator Support - Rear Lower. .
HHCS 5/ 16 x I ..............
650487
067695
Shroud . . ......................
HHCS 1/ 4 x 1/ 2 .............
650542
(9) 1/ 4 HLN 650803 - (5) 1/ 4 PW 654002 067698
Seal . . . . . . . . . . . . . . . . . . . . . . . . . .
067699
Fan Guard ....................
067708
Flywheel Adapter. . . . . . . . . . . . . . .
067710
Metric Screw . . .... ... ...... . ..
067711
Engine Sheave (6-7 / 8" Dia.) .....
067713
V-Belt..... . .... .. . . ... ... . ... .
067757
Metric Screw . .. . ...... .. . ... . .
067823
Nylon Insert Lock Nut.... ... . . .
067839
Baffle - Lower ... . .............
650486
HHCS 5/ 16 x 3/ 4 . .. . . . ... . ..
650542
HHCSI / 4xl / 2 .............
(2) 1/ 4 HLN 650803 - (2) 1/ 4 PW 654002
(2) 5/16 PW 654004
067840
Baffle - Rear .. . .. . ... . . ....... . 067845
Baffle - Front . . ............... . 650542
HHCS 1/ 4 x 1/ 2 ........ .... . (I) 1/ 4 HLN 650803 067882
Shutoff Control Cable . .. . ..... . (I) 3/ 8 NF HJN 653042 068218
Spacer .. . . ............ ... .... . 068336
Throttle Lever ......... . ... .. . . 650588
HHCS 1/ 4 x 1-1 / 2 ......... .. (2) 1/ 4 HLN 650803 068337
Friction Washer... . .. ....... .. .
068484
Muffler Support - Lower. . . . . . . .
650487
HHCS 5/1 6 x I ........ ..... .
(2) 5/ 16 PW 654004 068670
Fan Space r, ........ ; .... .. .. . . 068678
Trim (24") ....... ..... .... .. .. . 068960
Trim (12") . . .................. . 660017
Street Elbow 1/ 4 x 90° ......... . 660018
Street Elbow 1/ 8 x 90° ........ . . I
I
I
I
2
4
I
I
I
I
I
I
2
I
I
2
I
I
I
4
I
I
I
4
I
I
4
4
I
2
2
I
I
2
9
HL2800 - AXLE & DRIVE _ __ _ _ __ _ _ _ _ _ _ __ __ 38 26 19 ~20
20 \
19 37 ~/
26
~/
IMPORTANT: Order by Part Number - DO
NOT use Illustration Reference Numbers .
10
HL2800 - AXLE & DRIVE Ref.
No.
1
2
3
4
5
6
7
Part
No.
H8354
040775
042162
042163
046023
053329
053330
Part Name
No.
Req .
Retainer Washer ............... 2
Roll Pin 1/ 4 x 1-1 / 4 ............ 1
Bearing Cup ................ . .. 8
Bearing Cone .................. 8
Dust Cap ...................... 2
Wheel Seal .......... ; ......... 8
Idler Hub Assembled ........... 2
(Includes 520021 and 520054
Bearing Cups)
8 056287
Retaining Ring ................. 2
9 056669
Hole Plug ..................... 4
10 062030
Pump Drive Sheave (5" Dia.) . .. . 1
650893
SHCS 5/16 x 1-1/2 ........... 3
11 062033
Flexible Disc ................... 2
12 062034
Beaded Washer ................. 24
650894
SHCS 5/ 16 x 1 .. ....... ..... 3
(3) 5/ 16 HJN 653034
13 062035
Coupler - Left .................. 1
14 062039
External Retaining Ring ......... 2
15 062040
Bearing Support Shim .......... 4
16 062041
Bearing Support Shim .......... 6
17 062050
Transmission Shim ....... As Req'd.
18 062057
Idler Adjustment Washer ........ 2
19 062105
Pump Control Lever ..... . ...... 2
650579
HHCS 3/ 8 x 1-3 / 4 ........... 2
(2) 3/ 8 HLN 650805 - (2) 3/8 PW 654006
20 062109
Pump Control Bushing ....... . .. 2
21 062232
Bearing Support ................ I
22 062236
Bearing Support Spacer ........ . I
23 062367
Ball Bearing ................... 2
24 064349
Flange Coupling ................ I
650899
SHCS 3/8 x 1-1/4 ............ 1
650202
S-L SHSS 5/16 x 5/16 ........ 2
25 064352
Coupling - Center .............. 1
26 064353
Roll Pin 1/4 x 1 .............. 3
27 064354
Flange Bolt - 5/16 x I .......... 6
(6) 5/ 16 HJN 653034
28 064418
Dowel Pin 1/ 2 x 1-1 / 4 .......... 4
29 064423
Shim .......................... 4
30 065820
Wheel Hub Assembled ....... , .. 4 (Includes Cup No. 042162)
31 065823
Axle .......................... 4
655010 Cotter Pin 1/ 8 x I-I / 2 .......... 4
(4) 3/4 SN 650817
Ref.
No.
Part
No.
Part Name
No.
Req .
065829
Axle Bearing Shim ............. 12
Spacer ........................ 4
065830
067228
Screw Support ................. 2
HHCS 3/8 x 1-1/2 ........... 4
650533
(4) 3/8 LW 654026
35 067738
Spacer ....................... . 2
36 067739
Transmission Assembled - Right .. 1
(2) 5/ 16 HLN 650804 - (2) 5/ 16 PW 654004
Transmission Assembled - Left ... 1
37 067746
(2) 5/16 HLN 650804 - (2) 5/ 16 PW 654004
Chain Guard - Right ............ 1
38 067747
650547
HHCS 5/16 x 3-1 / 2 .... . ..... 4
(4) 5/16 HLN 650804
Chain Guard - Left ........... . . 1
39 067748
650547 HHCS 5/ 16 x 3-1 / 2 . ........... 4
(4) 5/16 HLN 650804
Axle Sprocket (44 T) ............ 4
40 067917
41 067920A
Chain - Right (No. 60H) of 168
Links Including One (047801)
Connector Link ............
42 067921B
Chain - Left (No. 60H) of 171 Links
Including One (047802) Offset
Link and One (047801) Con
nector Link ..... . ........ I
43 069226
Washer ................... . .... 4
44 069306
Idler - 16T .... . ..... . .......... 2
(Includes Bearing 520208)
45 069367
Idler (l4T) ..................... 2
655010
Cotter Pin 1/8 x 1-1 /2 ... . .... 2
(2) 3/ 4 SN 650817
46 069752
Washer ........... . ............ 6
47 520021
Bearing Cup ......... , ........ . 2
48 520022
Bearing Cone .................. 2
49 520054
Bearing Cup .............. . .. . . 2
50 520055
Bearing Cone .................. 2
51 520153
Bearing Lock Collar . . ..... . .... 2
32
33
34
A
B
For Replacement order 069474 Drive Chain - Right.
For Replacement order 069475 Drive Chain - Left.
11
HL2800 - REVERSING DRIVE _ _ _ _ _ _---.,.;.._ _ _ _ _ __ _ 1~
7
13,~
1~
~
NOT use Illustration Reference Numbers.
Ref.
No.
I
2
3
4
5
6
7
8
9
10
II
12
13
14
Part
No.
Part Name
No.
Req.
043691
Ball Bearing ...................
043693
Oil Seal . . . . . . . . . . . . . . . . . . . . . ..
046754
Bearing Housing ...............
059567
Retaining Ring.................
062367
Ball Bearing ........... . .......
067714
Sheave (5-1 / 2")...... . ..........
650202
S-L SHSS 5/16 x 5/16........
067716
Counter Shaft. . .. . .. . . .. . . . . . ..
067717
Transmission Support...........
650579
HHCS 3/ 8 x 1-3/4 ...........
(2) 3/ 8 HN 650603
650253
SQHSS 1/ 2 x 4-1 / 2 ..........
650250
SQHSS 1/ 2 x 3 ..............
(2) 1/ 2 HJN 653044
067725
Transmission Housing. . . . . . . . . ..
067727
Retaining Ring. . . . . . . . . . . . . . . . .
067728
Oil Seal.. . . . . . . . . . . . . . . . . . . . ..
067729
Shaft Spacer...................
067730
Gear - Right (48T) ......... " . . .
067731
Gear - Left (48T) ... ............
2
2
1
2
2
1
4
1
1
2
I
I
2
1
1
I
Ref.
No.
Part
No.
Part Name
15
067732
Output Shaft...................
655533
Woodruff Key 5/16 x 1".......
16 067733
Transmission Cover. . . . . . .. . . . . .
650448
HHCS 1/4 x 3/4 .............
(4) 1/4 LW 654022 17 067734
Transmission Cover Gasket. . . . . .
18 067735
Transmission Sheave (6 Dia.) . ...
650202
S-L SHSS 5/16 x 5/16 . ..... . .
19 067749
Reversing Transmission Assembled. . . . . . . . . . . . . . . . . . .
20 067977
Retaining Ring. . . . . . . . . . . . . . . ..
21 069806
Shaft Spacer .................. ,
22 071116
Belt...........................
23 520066
Ball Bearing... . . .. . . . .. . . .. . . .
24 520153
Bearing Lock Collar.. ..........
ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS 12
No. Req. 1
2
1
4
I
I
4
I
2
2
I
I
I
_ _ _ _ _ _ _ _ _ _ _ _ _ HL2800 - CONSOLE & CONTROLS ~28
(Y27 (!1
(i1
~~
25 0
,~ ,
I
~,
•
Ref.
No.
Part
No.
A162
2 054202
(4)
3 054841
4 054842
5 054901
6 061112
7 062093
(2)
8 062098
9 062100
(2)
10 062102
11 062103
(1)
12 062104
(1)
13 062110
14 062271
15 063847
Part Name
No.
Req.
Friction Spring. . . . . . . . . . . . . . . . . 2
Ball Joint. . . . . . . . . . . . . . . . . . . . . . 4
3/ 8 NF HLN 650840
Valve Lever. . . . . . . . . . . . . . . . . . . . 1
Clevis Pin ....... . ... . . . . . . . . .. 2
Friction Bar - Right ...... . ..... 1
Extension Spring ... , ...... " . .. 2
Tilt Control Rod .. . . . . . . . . . . . .. 2
3/8 NF HN 650552
Ball Pivot Plate - Left .. .. .. . .. . .
Friction Bar - Left.... . .. .. .. .. . 1
5/16 HLN 650804 - (2) 5/ 16 PW 654004
Friction Bar Spacer. . . . . . . . . . . . . 2
Steering Rod - Left. . . . . . . . . . . . . 1
3/ 8 NF HN 650552
Steering Rod - Right ...... . .... .
3/ 8 NF HN 650552
Rod End - L.H . Thread. . . . . . . .. 2
Connecting Link .......... . .... 1
Hexagon Nut - 3/ 8 N.F.
Left Hand......... ..... . .... 2
16 064151
Control Console.. .. . . . . . .. . .. . . 1
650486
HHCS 5/16 x 3/ 4 ............ 10
650488
HHCS 3/8 x 3/ 4 ............. 4
(6) 5/16 HLN 650804 - (8) 5/16 LW 654024 (12) 5/ 16 PW 654004 - (4) 3/ 8 LW 654026 Ref.
No.
Part
No.
Part Name
No.
Req.
17
064152
Guide Plate. . . . . . . . . . . . . . . . . . . . 1 650486
HHCS 5/16 x 3/ 4... ......... 2 (2) 5/ 16 LW 654024 - (2) 5/ 16 PW 654004 18 064155
Control Lever Latch. . . ... . . ... . 2 19 064157
Latch Pivot...... .. .. .. ..... ... I 20 064159
Lever Latch Rod . . . . . . . . . . . . . . . 1 650551
Cotter Pin 3/ 32 x 3/ 4.. . ...... 2 (2) 5/16 PW 654004 21 067675
Control Lever - Right ...... , . .. . 22 068299
T -Bar Cap ...... . .. . . . ... . .. . . . 650486
HHCS 5/16 x 3/ 4...... . . .... 3 (2) 5/16 HLN 650804 - (1) 5/16 L W 654024 (3) 5/ 16 PW 654004 23 068303
Side Trim - Right .. . .... . .... . . 24 068304
Side Trim - Left ... . ......... . . . 25 068305
T-Bar Cover Trim ... . .. . ...... . 26 068488
Control Lever - Left .......... . . (2) 5/ 8 HN 653021 27 068661
Lock Pin ...... .. .. . .......... . 650448
HHCS 1/ 4 x 3/ 4 ............ . (1) 1/ 4 HLN 650803 28 068663
Lock Pin Holder ........ . ..... . 650448
HHCS 1/ 4 x 3/ 4 ........... .. (1) 1/ 4 HLN 650803 ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS
13
HL2800 - TRANSMISSION _ _ __ _ _ _ _ _ _ _ _ _ _ __ IMPORTANT: Order by Part Number - DO
16
18 /'
/'
/'
/'
(
6
Ref.
No.
I
2
3
4
5
6
7
8
9
10
11
12
13
14
15
14
Part
No.
053331
059292
060107
061854
061857
064395
064420
Part Name
No.
Req.
Ref.
No.
Part
No.
Part Name
No.
Req.
Needle Bearing ................. 2
16 064410
Final Gear (50T) ..... . .........
Grease Seal ..... . .. . ..... . ..... I
17 064411
External Retaining Ring ....... . .
Final Gear Spacer ...... . .......
18 064412
Internal Retaining Ring ......... 2
Dust Cap .............. . .... . ..
Transmission Gasket . ..... . ..... 2
19 064415
Cover Gasket ....... . ........ . .
Shim ....................... . .. 2
20 064417
Transmission Housing - Right .... I
21 065240
Retaining Ring .................
Transmission Housing - Left .. . .. 1
22 065241
O-Ring .............. . . . . . .....
(Not Shown)
23 067740
Drive Sprocket (20T) ...........
064397
Primary Shaft ............ . . . ...
24 067741
Cover - Right ................. .
064398
650486
HHCS 5/16 x 3/ 4 ., ..........
O-Ring ................... .. ...
064399
(3) 5/16 PW 654004 Primary Gear - 15-34T ..........
064402
067795
Cover - Left (Not Shown) .... . . .
Cam Lock Bar ... .... ...... . . ..
650486
650488
HHCS 5/16 x 3/ 4 . ... . .... . . .
HHCS 3/ 8 x 3/ 4 . . ..... .. .. . .
(1) 3/ 8 LW 650426
(3) 5/16 PW 654004 064403
Bearing Cup ........ , ..........
Secondary Shaft ........... . ....
25 520046
064404
O-Ring ... . ...... .. . . .... . .. . ..
Bearing Cone ......... . ... .. ...
26 520048
064405
O-Ring .... . . . . .... . . . . . .. . .. . .
Needle Bearing .................
27 520138
064406
Double Gear - 19-40T ..... . ..... 064409
Output Shaft .... .. ............. 655010
Cotter Pin I / 8 x I-I / 2 ...... ..
(1) 3/ 4 SN 650817 - (1) 3/ 4 PW 654014 ALWAYS GIVE MOD EL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS
I
1
1
I
I
1
I
I
1
8
I
8
2
2
2
_ _ _ _ _ ________________ HL2800 - LOAD ARM IMPORTANT: Order by Part Number - DO
Part
No.
Ref.
No.
Part
No.
1 9H300
2 055021
650618
3 055910
4 062138
Part Name
No.
Req.
Lock Pin.............. ........
Hose Clamp. .. . . . . . . . .. . . .. .. .
HWHSTS 5/16 x 5/ 8 .........
Lock Pin........... .. .........
Lift Cylinder Bushing...........
1
1
I
2
2
Part Name
No.
Req.
062140
Tilt Cylinder Bushing. . .. . . . . . . .
650483
HHCS 3/ 4 x 5-1 / 2 ...........
062141
Attachment Bracket Spacer . . . . . .
062172
Safety Arm....................
062191
Attachment Pin.......... . .....
062216
Lift Arm Pin ........ . .. . .......
062417
Lift Cylinder Pin.............. .
064331
Lock Nut - 3/ 4........ .........
067552
Lift Arm.. ... ....... ...... . . . .
652088
CB 1/ 2 x 3-1 / 2...............
(1) 1/ 2 HLN 650806
13 067559
Attachment Bracket. . . . .. . . . . . . .
650172
HHCS 3/ 4 x 3-1 / 4 .. ........ .
650526
HHCS 3/4 x 6 .......... .....
14 067751
Hose Guard.... .. ........ .. ...
2
2
2
1
2
2
2
8
1
1
I
2
2
1
ALWAYS GIVE MODEL AND SERIAL NUMBER WHEN ORDERING SERVICE PARTS 15
HL2800 - HYDRAULICS _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ IMPORTANT: Order by Part Number - DO
44
28
30 ~!, 31
16
HL2800 - HYDRAULI CS
Ref.
No.
1
2
3
4
5
6
7
8
9
10
II
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
Part
No.
054854
054982
055335
055648
055896
056309
057655
057991
058654
058859
Part Name
No.
Req.
3
1
Hose Clamp ................... 15
90° Male Elbow - 3/ 4 ...........
90 0 Male Elbow - 3/ 4 ... . ..... . .
Wire Tie ...................... 13
O-Ring ..... . ........ .. ........ 4
90 0 Barb Fitting - 5/ 8 ........... 1
Pipe Reducer 1/ 2 x 3/ 8 ......... 2
Male Tee .. . .... . ... . .......... 1
90 0 Street Elbow ......... . ..... 1
Male Connector 1-1 / 16 x 3/ 4 .... 2
w/ O-Ring . ......... . ... .. ... 2
061510
Oil Filter .. . .......... . ...... . . 2
061511
Replacement Element .......... I
061514
Hydro-Transmission - Right ..... I
650491
HHCS 3/ 8 x 1-1 /4 ...... .... . 4
Hydro-Transmission - Left. ...... I
061515
650491
HHCS 3/ 8 x 1-1 / 4 .. ...... ... 4
061519
Oil Cooler ............. .... ... . 1
650486
HHCS 5/16 x 3/ 4 .... ... ..... I
(1) 5/ 16 PW 654004
061524
Towing Clip ................... 2
061580
Male Pipe Adapter . .... . ...... . I
062020
Male Pipe to Barb Coupling - 1/4 I
062022
Fuel Line 90 0 Elbow ............ I
062023
Hose Clamp ................... 3
062024
Hose 1/ 4 x 30 . .. ...... .. ...... . I
062128
90° Elbow ... . .... . .......... .. I
062129
45° Elbow ......... .. .......... I
062135
90° Male Pipe Elbow ... . ....... 1
062272
Relief Valve ................... 2
062273
Adapter ...................... . 4
062275
Swivel Adapter .. . . . ............ 4
062392A Tilt Cylinder ................... 2
570004
Grease Fitting - 65° ........... 4
062394A Lift Cylinder ................. . . 2
570004
Grease Fitting - 65° .... . ...... 2
570005
Grease Fitting - 90° .... . ... . .. 2
062399
Valve to Lift Cylinder (Rod End)
Hose 3/ 8 x 40 ................ I
062405
90° Male Elbow 3/ 8 x 1/ 2 ... . ... 7
062408
Valve to Tilt Cylinder (Rod End)
Hose 3/ 8 x 156 ...............
062409
Male Connector .......... . .....
062410
Male Branch Tee ........ .. .....
062411
Tee to Tilt Cylinder (Rod End)
Hose 3(8 x 19 .... , ..... , .....
Ref.
No.
Part
No.
Part Name
No.
Req.
35 062412
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
Valve to Tilt Cylinder (Blank End)
Hose 3/ 8 x 140 ... .... . .. .. ...
063070
Control Valve . .. . .. ....... .. .. .
650492
HHCS 3/ 8 x 2-1 / 2 . .... ..... .
(3) 3/ 8 HLN 650805
063592
Sta Strap .................... . .
065355
Barb Fitting - 5/ 8 ..............
065810
Return Hose I x 18 . . .. ..... . ...
065904
Washer ... . .... .. ......... . . . . .
065905
Gasket ........................
067137
Gear Pump . ....... . .. . .. .. ....
067673
Lock Washer
067753
Lift Cylinder Pin ....... .. ......
067757
Metric Screw .. ..... .. .. . . . . . ..
067760
Suction Hose I x 10 .......... . .
067761
90 0 Male Elbow ... . ... . . . . ; .. . .
067762
Hose 1/ 2 x 48 .. ......... . ... . . .
067763
Return Hose 3/4 x 16 .. ... ... . ..
067764
Oil Cooler Support - Lower .. . . . .
067765
Oil Cooler Support - Upper .. . . . .
(1) 5/ 16 PW 654004
067767
Suction Hose - Right 3/4 x 55 .. .
067768
Suction Hose - Left 3/4 x 48 .....
067769
Tee .............. . .. .. .. . . . ...
067771
Hose 3/8 x 54 . . ... . ... .. .... ...
067772
Hose 3/ 8 x 72 . ....... . .... .....
067978
Return Hose I x 42 ......... . . ..
068223
Hose 5/ 8 19 ... ... . .. . ...... . . .
068228
Male Elbow ............... .. ..
068665
Sheave (6.90 Dia.) ..............
068667
Sheave (6 Dia.) .................
068668
Hub .... . ........... .. . .. . ... .
068669
Belt Set . . ... . ....... . .... . . . . .
069194
45° Swivel Elbow ........... .. ..
660010
90° Elbow - 3/4 .... . . . . . .. .... .
660038
Pipe Nipple - 3/ 4 x 4 ...... . .. . .
660064
Pipe Nipple - 3/ 4 x 2-1/2 .... .. . .
660076
Pipe Nipple - 3/ 4 x 1-1 / 2 ........
••
••
•
•
• • • • • • • • to
•••
I
I
3
2
I
2
2
2
1
4
2
4
I
I
1
1
I
1
I
I
2
2
2
I
I
I
I
I
I
I
I
2
2
2
2
A Replacement Cylinders must be used in pairs, or if
singly must match other one of pair being replaced .
Use Replacement Parts 062137 and 062139 or
Parts 062394 and 062393.
17
HL2800 - MECHANICAL BRAKE _ __ _ _ _ _ _ _ _ _ _ __ ~9 11 7
2
Ref.
No.
Part
No.
Part Name
No.
Req.
1 064962
Bronze Bushing ................
2 067821
Mechanical Brake ..............
Brake Mounting Stud ...........
3 067822
HHCS 5/ 8 .. ................. .
067609
4 067823
Lock Nut - 5/ 8 .... . .... . .......
Bearing Support - Left . . ........
5 067831
Bearing Support - Right .........
6 067834
Bearing - Right ............ . ....
7 067884
067827
HLN 3/ 8 ............ ........
650533
3/ 8 x 1-1/2 HHCS ...........
(2) 3/8 PW 654006
Bearing - Left ... . ..............
8 067885
HLN 3/ 8 .... ..... ..... . .....
067827 650533
3/ 8 x 1-1 / 2 HHCS ...........
(2) 3/ 8 PW 654006 ALWA YS GIVE MODEL AND SERIAL
18 2
2
4
4
4
1
1
1
2
2
Ref.
No.
Part
No.
Part Name
No.
Req.
Female Ball Joint. ......... . .... 4 068319
(2) 1/ 4 NF HN 650546 - (2) 1/ 4 L W 654022 Male Ball Joint ................ 2 10 068339
(4) 1/ 4 NF HN 650546 - (2) 1/4 LW 654022 Brake Lever ......... ~ ... .... . . 1 11 068628
HHCS 5/16 x 3/ 4 ............ 2 650486
(4) 5/ 16 PW 654004 1
Threaded Brake Rod . ........... 12 068664
2
(2) 1/4 NF HN 650546 2
Actuator Tube ........ . ........ 13 069276
NU MBER WHEN ORDERING SERVICE PARTS
9
_ _ _ __ _ _ _ __ _ _ _ _ HL2800 - ELECTRICAL SYSTEM IMPORTANT: Order by Part Number - DO
31 20
30 @~
7
10/
~-
~
,
~
I /a~() CJ 19 )
/ "0"1 ~ 9 \
00
17~18~16
\r~~15 .f((
8 9
23 24 Ref.
No.
1
2
3
4
5
6
7
8
9
10
II
12
13
14
15
16
17
Part
No.
Part Name
No.
Req.
054931
Dead Man Switch. . . . . . . . . . . . . .
054984
Ground Cable. . .. .. .. . . .. . .. . . .
054985
Solenoid Cable. . . . . . . . . . . . . . . . .
056773
Hose Clamp ... . . . . . . . . . . . . . . ..
650618
HWHSTS 5/16 x 5/ 8....... . .
(3) 5/ 16 LW 654024
058010
Battery Hold-down. .. . . .. . . . .. .
062147
Vacuum Switch.. . . . . . .. .. . . ...
063065
Wire - Ignition Switch to Ammeter
063067
HourmeterGround Wire. .. . . . . .
063073
Warning Light .................
063467
Connector. . . . . . . . . . . . . . . . . . . ..
063999
Battery -12 Volt...............
067773
Battery Hold-down Bolt. . .. . .. ..
650551
Cotter Pin 3/32 x 3/4..... ....
(4) 5/16 PW 654004
067774
Battery Tray .................. .
067777
Battery Cable .............. . .. .
067779
Fuel Gauge ................... .
067781
Water Temperature Gauge ...... .
067782
Hourmeter .................... . 1
1
1
3
3
I
2
I
I
2
4
I
3
2
Ref.
No.
Part
No.
Part Name
No.
Req.
18 067783
Ammeter. . . . . . . . . . . . . . . . . . . . . .
19 067784
Oil Pressure Gauge . . ....... . .. .
20 067785
Horn. . . . . . . . . . . . . . . . . . . . . . . . .
650469
PTHMS 1/4 x 3/4 ...........
(2) 1/ 4 HLN 650803 21 067786
Instrument Harness. . . . . . . . . . . . .
22 067787
Engine Harness ...... . .........
23 067788
Gauge Ground Wire . . . . . . . . . . . .
24 067789
Gauge Power Wire. . . . . . . . . . . . .
25 067790
Glow Plug Wire. . . .. . . . . . . . . . . .
26 067791
Jumper Wire ............ , . . . . ..
27 067792
Jumper Wire. . . .. .. . . . . . . .. . .. .
28 067841
Battery Shield. . . . . . . . . . . . . . . . . .
650486
HHCS 5/ 16 x 3/4 .... . ...... .
(I) 5/16 PW 654004 29 068040
Button to Horn Wire . ..........
30 068041
Ignition to Horn Wire. . . . . . . . . . .
31 069028
Battery Cover. . . . . . . . . .. . . . . . ..
32 660017
Street Elbow 1/4 x 90° ..........
33 660043
Reducing Bushing.. . ... . . .. . . . .
I
I
1
2
I
I
1
I
2
I
1
I
1
I
I
1
2
2
19
HL2800 - LI FT and TILT DRIVE -
- -- - - - - - - - - - -
25
10
/.
<'
O~
IM PORTA NT: Order by Part Number - DO
21
19~~
llr~
18
~(f;)
16 13~PO~4
17/~
Ref.
No.
I
2
3
4
5
6
7
8
9
10
J1
12
13
14
15
16
17
Part
No.
063070
047699
047707
047708
047709
047711
047714
047721
047722
047724
06 1188
066787
066788
066789
066790
066791
066792
066793
Part Name
No.
Req.
Control Valve Assembled . . . . . . . . I
Stop Collar. . . . . . . . . . . . . . . . . . . . I
Housing* . . . . . . . . . . . . . . . . . . . . . . I
4-Way Spool*... .... . ..... ..... I
4-Way Float Spool* ............ I
Collar Float Spring. . . . . . . . . . . . . I
Conversion Plug Kit . .. . . . . . .. .. I
Detent Sub-Assembly... ... . . . . . I
Shoulder Bolt. . . . . . . . . . . . . . . . . . I
Detent Plunger. . . . . . . . . . . . . . . . . I
Check Plug Kit. . . . ............. 2
Relief Valve Ball . .. .... ... .. . .. I
Shim .................... As Req'd .
Relief S pring Washer ......... . . I
Lock Washer....... ....... .... I
S pring, Float Centering ..... . ... I
Relief Spring. . . . . . . . . . . . . . . . . . . I
Relief Valve Body.... . .. . ...... 1
Ref.
No.
18
19
20
21
22
23
24
25
26
27
28
Part
No.
066794
066795
066796
066797
580006
580013
580014
580015
580030
580033
580039
Part Name
Guide.... . . .. . . ...... .. .......
Relief Valve Seat . . . . . . . . . . . . . . .
Shim Washer.... .. .. . .. . . .. .. .
Gasket O-Ring Seal Kit. . . . . . . . .
Bolt, Spring . .. ......... . ..... .
Stop Disc .. . . . ..... . ... . ......
Centering Spring. . . . . . . . . . . . . . .
Snap Ring. . .. . . . . . . . . . . . . . . . . .
Seal** . . .... . . . .. . ... . ... . ....
Bonnet, Rubber. . . . . . . . . . . . . . ..
Stop Washer. . . . . . . . . . . . . . . . . ..
1
I
1
I
I
I
1
1
4
2
2
* Housing and Spools may NOT be ordered as separate
items.
All Spools are fitted to individual housing at factory.
** Tool #060644 necessary for installation.
20
No.
Req.
HL2800 - GEAR PUMP tMPORTANT: Order by Part Number - DO
3
~
2
3
~
Ref.
No.
Part
No.
1 067139
2 067140
650917
650896
3 067141
Part Name
No.
Req.
Body ..........................
Cover .........................
SHCS 3/ 8-16 x 1-1/2 .........
SHCS 5/ 16-18 x 1-1 / 4 ........
Dowel Pin .....................
1
1
4
4
2
Ref.
No.
Part
No.
4 067145
5 067146
650688
6 069248
Part Name
No.
Req .
Idler Shaft .................. . ..
Drive Gear ............ . . ..... .
Woodruff Key - 5/ 32 x 5/8 ....
Pump Seal Kit .................
21
HL2800 - HYDRAULIC CYLINDERS _ _ _ _ _ _ _ __ _ _ __ NOTE: Identifing mark (L-Month-Year)
should be located near Port on Lug
End of Cylinder.
10 7
9
//000 O@])'@~
~.k:»
\
/
~ -- -- - ------- - ------- - --------- -- --- -- -- --- ------- - - ------- - -- - - --- ----- - ----7
~~-~l{~--NOT-E: ~;~Of~ ~50 O ~/
N-otC---.J
h
(Lantex)
Gland on Rod End. 3
rr\\ O·
M])~
O
u(J) U VJ U G ~ d:
~ g~_L-~"-4~
14
9
13
~
,/
I
L - - -
-
- -
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-- -
-
-
- - - -
-
NOTE: Identlfing mark (L-Month-Year)
~~--- should be located near Port on Lug
-
-
-
-
- -
-
-
-
-
-
- -
-
-
End of Cylinder.
0
-
- 7
/
~r---7.....-----'~ ~ 0~ Q0 OJ/
12
15
NOTE: Notch each side of
Gland on Rod End.
26
(Lantex)
4
1
NOTE: Identifing mark (GEe)
should be located nea r Port
on Lug End of Cylinder.
22
/~···· ~OO O~~ ~
r
;q>)------'
I
LI ________ _
_
_
_
__ _
_
_____ _
_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ __ _
~
24
/
I
~
\~QOQ(Q)m 0 O~/
21
2
23
C
NOTE: Head has 1/4" Flat
on Rod End.
(Columbus)
5
16 1
20
~
/F~(Q) 0 (Q)
\J
~,
® I
L _ _ _ _ _ _ _ _ _ _ _ __ _ _ __ _ _
__ _
NOTE: Identifing Mark (GEC)
~ ~hOUld be located near Port
\
~n Lug End of Cylinder. cr:~~---4\------'«~
______ _ _
_
_
_
_
--- - - -- - -- -- -- - - -
--------.--'}-SNO-T-'E:
on Rod End.
6
- -
-- -
-
- -
-
~/~F~ @~ 0
17 a
22
- - -- - -
- -- -
- -
- ~
i
O(COlumbUSl
- -_ _ _ _ _ _ _ _ _ _ _ HL2800 - HYDRAULIC CYLINDERS Ref.
No.
I
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Part
No.
055071
057157
062137A
062139B
062393c
0623950
064295
064296
064297
064298
064299
064301
064302
064303
064304
064305
Part Name
No.
Req.
Nut...........................
Snap Ring... .... .... ... . ... . ..
Lift Cylinder. . . . . . . . . . . . . . . . . . .
Tilt Cylinder. . . . . . . . . . . . . . . . . . .
Tilt Cylinder. . . . . . . . . . . . . . . . . ..
Lift Cylinder. . . . . . . . . . . . . . . . . ..
Barrel.........................
Cylinder Gland. . . . . . . . . . . . . . . . .
Nut...........................
Piston.........................
Rod..........................
Rod..........................
Barrel. . . . . . . . . . . . . . . . . . . . . . . . .
Piston. . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Gland. . . . . . . . . . . . . . . . .
Piston. . . . . . . . . . . . . . . . . . . . . . . . .
1
1
2
2
2
2
I
I
1
I
1
1
1
1
1
1
Ref.
No.
17
18
19
20
21
22
23
29
25
26
Part
No.
064306
064307
064310
064311
064313
064315
064317
064318
066564
066565
Part Name
No.
Req.
Snap Ring .................... .
Head ........................ .
Rod ......................... .
Barrel ........................ .
Rod ......................... .
Barrel ........................ .
Head ........................ .
Piston ........................ .
Lock Wire .................... .
Lock Wire .................... .
A To order Cylinder Seal Kit, specify Part No. 064294.
B To order Cylinder Seal Kit, specify Part No. 064300.
c To order Cylinder Seal Kit, specify Part No. 057148.
o To order Cylinder Seal Kit, specify Part No. 064309.
23
HL2800 - HYDROSTATIC TRANSMISSION _ __ _ _ _ _ _ __ 47
IMPORTANT: Order by Part Number - DO NOT use Illustration Reference Numbers. 36 'k 43
~~'-,A,~ ~
i~~28
i5 ~5 ~r
16
1 2 ~27
36
., ""
3~~\J26 ~')~.
~~
l461hl~'~
~~20
38~
21
Ref.
No.
24
Part
No.
064394
064419
I 064335
2 064336
3 064338
4 602075
5 602076
6 602078
7 602080
8 602081
9 602082
10 602083
II 602084
12 602085
13 602086
14 602088
15 602089
16 602090
17 602091
18 602092
19 602094
20 602095
21 602096
22 602097
23 602099
24 602100
25 602101
~\\46'22
Part Name
34
48
19
No.
Req.
Transmission Assembled - Right. .
Transmission Assembled - Left. . .
Charge Pump Housing* . . . . . . . . .
Gerotor* .............. . .......
Housing Gasket. . . . . . . . . . . . . . . .
Motor Shaft. . . . . . . . . . . . . . . . . . .
Straight Headless Pin. . . . . . . . . . .
O-Ring*. . . . . . . . . . . . . . . . . . . . . . .
Straight Headless Pin* ...... . . . .
Pump Shaft. . . . . . . . . . . . . . . . . . . .
Relief Valve Cone.. . . . . . . . . . . . .
Relief Valve Spring. . . . . . . . . . . . .
O-Ring. . . . . . . . . . . . . . . . . . . . . . . .
Plug. . . . . . . . . . . . . . . . . . . . . . . . . .
Straight Headless Pin. . . . . . . . . ..
Cylinder Block Kit. . . . . . . . . . . . ..
Retaining Ring. . . . . . . . . . . . . . . ..
Trunnion Shaft .................
S pring Pin. . . . . . . . . . . . . . . . . . . ..
Trunnion Shaft. . . . . . . . . . . . . . . . .
Hexagon Head Cap Screw. . . . . . .
Plain Washer ..................
Hexagon Head Cap Screw. . . . . . .
Hexagon Head Cap Screw. . . . . ..
Pipe Plug.. .... . ... .... . . ......
Threaded Plug .. . . . . . . . . . . . . . ..
12 Point Cap Screw. . . . . . . . . . . ..
I
I
I
I
I
I
2
I
I
I
I
I
I
I
2
2
2
I
3
I
I
2
2
4
2
2
2
Ref.
No.
26
27
28
29
30
31
32 33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
Part
No.
602102
602103
602104
602108
602109
602110
602111
602123
602112
602113
602114
602115
602118
602120
602121
602423
602424
602425
602426
602427
602428
602429
602431
602432
602433
Part Name
No.
Req.
12 Point Cap Screw ............. 2 Hexagon Head Cap Screw. . . . . . . I
Washer. . . . . . . . . . . . . . . . . . . . . . . . 2
Shim Pack .............. . As Req'd.
Ball Bearing ................... I
S wash Plate ................... I
Valve Plate - Right. . . . . . . . . . . . . I
Valve Plate - Left. . . . . . . . . . . . . . . I
Variable Swash Plate. . . . . . . . . . . I
Valve Plate.. . . .. . ....... .. . . . . I
Thrust Plate .. . . . . . . .. . . . . . . . . . I
Lip Seal* ...... .... ........ . . .. 2
Needle Bearing* . . . . . . . . . . . . . . . . I
Pipe Plug........ .. . . . ......... I
Needle Bearing. . . . . . . . . . . . . . . .. 2
O-Ring....................... . 2
Back-up Ring. . . . . . . . . . . . . . . . . . 2
O-Ring. . . . . . . . . . . . . . . . . . . . . . . . 2
Roller Bearing ................. I
Lip Seal. . . . . . . . . . . . . . . . . . .. . . . 2
Needle Bearing. . . . . . . . . . . . . . . . . 2
O-Ring........................ 2
Housing
.............. I
Center Section ................. I
Check Valve
.......... 2
*To order parts, specify Charge Pump Kit
Number 066798.
24
15
HL2800 - ACCESSORIES _ _ _ _ _ _ _ __ _ _ _ _ _ _ __ UTILITY BUCKET
(50" Wi de - Ca pa city 5.7 Cu. Ft.)
Ref.
N o.
Part
No.
062326
UTILITY BUCKET (54" Wide - C apacity 6-3/4 Cu. Ft.) No.
Req.
Part Name
Ref.
No.
Utility Bucket .. . . . .. . ......... .
To ord er Replacement Cutting Edge, specify part
Part
No.
062298
No.
Req .
Part Name
Utility Bucket .. . . . .. .. . ....... .
To order Replacement Cutting Edge, specify part
number 062299.
number 062327.
~1 ~1 LIGH T MATERIAL BUCKET
(72" Wide - Capacity 15 Cu. Ft.)
R ef.
1\'0.
P art
N o.
0623 13
Part Name
No .
Req.
Light Material Bucket .. .... . ... .
To order Replacement C utting Edge, specify part
number 062 3 14.
~-----------------------------------~
FERTILI ZER BU CK ET
(54" Wide - Capacity 12 Cu. Ft. Struck)
R et.
N n.
Part
No .
Part Name
PR ODUCE BUCKET (60" Wide - Capacity 11 Cu. Ft.) No.
Relj.
I 062329
Fe rtilizer Bucket. ..... . ... . ... . . To ord er R eplace ment Cutting Edge, specify part
number 062299.
Ref.
No.
Part
No .
062304
Part Name
No.
Req.
Produce Bucket .. ... . . . ....... . To order Replacement Cutting E dge, specify part number 062305. *Screen portion is not used in determining capacity.
26
_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ HL2800 - ACCESSORIES MAN URE FORK
(54" Wide - 1 Tines)
Ref.
No.
I
Part
No.
062319
Part Name
No.
Req.
Manure Fork .. .......... . .... . To order Short Tine, specify part number 062323.
To order Long Tine, specify part number 062324.
To order Tine Support Gusset, specify part number
064261.
To order Center Tine Support, specify part number
062325.
Ref.
No.
PALLET FORK (30" Forks - Adjustable Width) Part
No.
Part Name
I 064160
2 064167
3 061540
DRAWBAR
No .
Req.
Pallet Fork Carriage. . . . . . . . . . . .
Pallet Fork .... . . . ... . .. . ... . . .
Pallet Fork Backrest. . . . . . . . . . . .
Ref.
No.
I
2
I
Part
No.
Part Name
No.
Req.
062547
Drawbar .......... . .......... .
650453
HHCS 1/ 2 x 1-1/2 ...........
(2) 1/ 2 HLN 650806
I
2
BUCKET TOOTH
Ref.
No.
Part No. I 055944 2 058388 Part Name
No.
Req.
Bucket Tooth. . . . . . . . . . . . . . . . ..
Bucket Tooth Point. . . . . . . . . . . ..
8
8
27
HL2800 - ACCESSORIES _ __ _ _ _ _ _ _ _ _ __ _ __ GRAPPLE FORK
R ef.
No.
Part
No.
Part Name
No.
Req.
056080
2
3
4
5
6
Quick Disconnect - Male
(N ot Shown) . . . . . . . . . . . . . . . ..
062140
Bushing.... .... ...... .... .... .
062392
Hydraulic Cylinder ...... .. .....
062405
EI bow - Male (N ot Shown) . . . . . .
Sta Strap (Not Shown). . . ... . . ..
063592
063873
Grapple Fork. . . . . . . . . . . . . . . . . .
650711
HHCS 3/ 4 x 3 ...............
(I) 3/4 H LN 650828
Ref.
No.
7
2
2
1
2
I
I
I
8
9
10
Part
No.
Part Name
063879
Grapple Mount ............... . 570002
Grease Fitting. . . . . . . . . . . . . . ..
650491
H H CS 3/8 x I-I /4 .... .. .... .
(6) 3/ 8 HLN 650805 063881
Cylinder Mounting Bracket. . . . . .
650491
H H CS 3/ 8 x 1-1 / 4 ..... . .....
(4) 3/8 HLN 650805 - (4) 3/ 8 PW 654006 650711
HHCS 3/ 4 x 3 ......... , ... . . (I) 3/4 HLN 650828 063884
Hose (N ot Shown) ............. . 063885
Hose (Not Shown) ........ . .... . 6
28
No.
Req.
2
6
I
4
HL2800 - ACCESSORIES 801382
Light Kit
!;?
18"-0 "-8
~18
ty'16
~18 7
~
14
Part
Ref.
Part Name
No.No.
801382
1
2
3
4
5
6
7
8
9
055648
055921
055922
055923
055924
055925
055926
055927
055928
No.
Req.
Light Kit ......................
Consists of: Wire Tie ......................
Work and Tail Lamp ...........
Head Lamp ... ... ... ...........
Light Switch ...................
Toggle Switch ..................
Heavy Duty Flasher ............
Reflector ......................
Male Snap-on Terminal .........
Vinyl Boot .....................
Ref.
No.
IO
II
6
I
2
I
I
I
2
6
5
12
13
14
15
16
17
18
19
20
21
Part
No.
055929
055931
055933
055934
055955
058615
063064
063466
063467
063468
063853
063854
No.
Req.
Part Name
Warning Lamp .................
Wire ..........................
Wire ..........................
Flasher Mounting Bracket .......
In-Line Fuse . ... ...............
Insulated Wire Clamp ... . .......
Clip ..........................
Wire Harness ....... ..... .. ....
Electric Connector ........... .. .
Light Bracket ...... . ...........
Wire - Headlight ........... ....
Wire - Headlight
•••••••••
,0
•••••
2
1
1
I
I
1
2
I
6
2
1
1
29
HL2800 - ACCESSORIES _ _ _ _ _ _ _ _ _ _ _ _ __ __ 801788 Front Hydraulics Kit
24
Ref.
No.
Part
No.
Part Name
HL2800 Front Hydraulics Kit .. . .
Consists of:
051387
Dust Plug ... . .................
051392
Auxiliary Valve ..... ..... ... .. .
650535
HHCS 3/ 8 x 2-1/4 ...........
(3) 3/ 8 HLN650805 - (3) 3/8 PW 654006
051393
Power-Beyond Sleeve ...........
054841
Valve Lever ....................
054842
Clevis Pin .....................
650590
Cotterpin 1/ 16 x 1/2 . .... .. ...
054856
90 0 Male 37 0 Adapter - 3/4" Tube
054982
90 0 Elbow - 1/2" Tube to
3/ 4" Pipe ..... .. .... ... . .... .
055021
Hose Clamp . .......... ....... .
650486
HHCS 5/ 16 x 3/ 4 ............
650618
HWHSTS 5/ 16 x 18 x 5/8 ....
(4) 5/16 PW 654004
056076
N on-skid Strip .................
056089
Female Run 37 0 Swivel Tee ......
062271
Connecting Link ...............
062274
Straight Adapter 1/ 2" Tube to
1/ 2" Pipe ........... . ........
062408
Hose 3/ 8 x 156" ................
063592
Nylon Sta-strap . . ..............
064238
yoke ......... ..... ........ . ...
064239
Yoke Pin ..... . ................
801788
I
2
3
4
5
6
7
8
9
IO
11
12
13
14
15
16
30
2
I
3
Ref.
No.
I
I
4
2
3
1
I
Part Name
No.
Req.
064245
Pedal Pivot .................... 1
650487
HHCS 5fl6 x I .............. 2
(2) 5/ 16 HLN 650804
18 064247
Pedal .. .... ... .. ... ..... ......
650493
HHCS 3/ 8 x 2-3/4 .......... .
(I) 3 / 8 HLN 650805
19 064251
Coupling Mounting Bracket ..... I
Female Quick-disconnect ........ 2
20 064252
21 064253
Coupler Retaining Ring . ....... . 2
22 064254
Hose 3/ 4 x 36 .................. 1
Lift Arm Hose Guard . ........ . . I
23 067751
650545
HHCS 5fl6 x 1-1 / 4 ......... . 3
24 068226
Left Panel ... ..... . ... . ...... . . 1
650487
HHCS 5fl6 x I ... . .......... 4
(2) 5/16 HLN 650804 - (4) 5/16 PW 654004
25 068245
Control Link ................... 1
(I) 3/ 8 NF HN
(1) 3/8 HLN w/Nylon Insert 064260
Hose 1/ 2 x 28" ................ .
26 069229
27 069236
45 0 Swivel Elbow .......... .....
Hose 3/4 x 30 .. . ...............
28 069294
17
2
2
Part
No.
_ _ _ _ _ __ _ _ _ _ __ _ _ HL2800 - NUMERICAL INDEX Part No.
Page No .
A162 . .. .......... 13
9H300 .......... 7,15
H8354 ............ II
040000
040775
042162
042163
043691
043693
046023
046754
047269
047699
047707
047708
047709
047711
047714
047721
047722
047724
047801
047802
........... II
...... ..... II
........... II
........... 12
........... 12
....... .. .. II
........... 12
..... ... .. .. 7
.. . ... ..... 20
........... 20
. .. . .. . .... 20
. .. . ....... 20
........... 20
....... .... 20
........... 20
.......... . 20
........... 20
........... II
.......... . II
050000
051387
051392
051393
053329
053330
053331
054202
054841
054842
054846
054854
054854
054885
054901
054931
054959
054982
054984
054985
055014
055015
055016
055018
055021
055030
055071
055335
055648
055896
055910
055913
055921
055922
055923
055924
........... 30
........... 30
.... ....... 30
........... II
........... II
........... 14
........... 13
........ 13,30
.. ... .. . 13,30
............ 7
........... 17
.. .. .. ..... 30
............ 9
........ ... 13
........... 19
............ 9
... ..... 17,30
........... 19
...... ..... 19
.. .......... 9
............ 9
............ 9
............ 9
....... 7,15,30
.... .. ...... 9
.... ....... 23
.. .... ..... 17
........ 17,29
.... ....... 17
........... 15
............ 9
........... 29
........... 29
...... ..... 29
.......... . 29
Part No.
055925
055926
055927
055928
055929
055931
055933
055934
055944
055955
056076
056080
056089
056287
056309
056669
056773
056815
057148
057157
057655
057991
058010
058388
058615
058654
058859
059292
059567
Page No.
........... 29
......... .. 29
........... 29
........... 29
.......... . 29
.. .. ....... 29
........... 29
........... 29
........... 27
.. ........ . 29
.......... . 30
........... 28
.. . . ... . ... 30
........... 11
........... 17
.......... . II
...... ..... 19
............ 9
........... 23
........... 23
........... 17
........... 17
........... 19
........... 27
........... 29
........... 17
........... 17
........... 14
........... 12
060000
060039
060107
060644
061II2
061166
061188
061510
061514
061515
061519
061520
061524
061540
061580
061854
061857
061859
062013
062016
062017
062019
062020
062022
062023
062024
062030
062033
062034
062035
..... ... .... 9
.......... . 14
........... 20
........... 13
. . . ....... .. 9
........... 20
........... 17
........... 17
......... . . 17
........ ... 17
............ 7
........... 17
........... 27
........ ... 17
........ .. . 14
........... 14
............ 7
............ 7
............ 7
............ 7
.... . ....... 9
.... . ... ... 17
. ... ....... 17
.... ..... 9,17
..... . ..... 17
........ ... II
.... . .... .. II
........... II
.......... . II
Part No.
062039
062040
062041
062050
062057
062093
062098
062100
062102
062103
062104
062105
062109
062110
062111
062II8
062128
062129
062130
062135
062137
062138
062139
062140
062141
062147
062172
062191
062216
062232
062236
062271
062272
062273
062274
062275
062282
062298
062299
062304
062305
062313
062314
062319
062323
062324
062325
062326
062327
062329
062367
062392
062393
062394
062395
062399
062405
062408
062409
Page No.
..... ..... . II
.. .... ..... 11
....... . . .. 11
.... ....... II
... .. ... ... 11
...... ..... 13
.... ... .. .. 13
. . .. ... . .. . 13
....... .... 13
.. ........ . 13
........ ... 13
........ ... 11
.. .. . ...... II
........ ... 13
. ....... .... 7
.. .... ...... 7
.. .. .... ... 17
.... ....... 17
............ 7
........... 17
....... . . .. 23
.......... . 15
. ....... 17,23
.... .. .. 15,28
........... 15
........... 19
........... 15
...... ..... 15
.. ... ..... . 15
..... ...... 11
........... 11
..... ... 13,30
........ ... 17
.... ...... . 17
........... 30
...... ..... 17
... .. . . ..... 9
........... 26
........... 26
......... .. 26
.... . ..... . 26
... .... .... 26
........... 26
... ..... ... 27
........... 27
........... 27
........... 27
... . ....... 26
........... 26
........... 26
..... .. . 11,12
....... . 17,28
........ 17,23
. .......... 17
........... 23
........... 17
........ 17,28
........ 17,30
.... .. ..... 17
Part No.
062410
062411
062412
062417
062547
063064
063065
063067
063070
063073
063436
063466
063467
063468
063592
063847
063853
063854
063873
063879
063881
063884
063885
063999
064151
064152
064155
064157
064159
064160
064167
064238
064239
064245
064247
064251
064252
064253
064254
064261
064270
064294
064295
064296
064297
064298
064299
064300
064301
064302
064303
064304
064305
064306
064307
064309
064310
064311
064313
Page No .
........... 17 ........... 17 ...... .... . 17 ........... 15 .... . ...... 27 .......... . 29 . ... .. ..... 19 .......... . 19 ........ 17,20 ........... 19 .... ........ 7 . ... ..... . . 29 ....... . 19,29 .... . ...... 29 ...... 17 ,28 ,30 .......... . 13 ........... 29 ..... .. .. .. 29 ........ ... 28 ... .. . ..... 28 . . .. .... ... 28 .... ..... .. 28 ........... 28 . . ......... 19 .......... . 13 ........... 13 .. ........ . 13 ........... 13 .... .. ..... 13 . ..... ... .. 27 .......... . 27 ........... 30 ........... 30 ........... 30 .... ....... 30 ........... 30 .......... . 30 ..... ...... 30 ..... .. .. .. 30 ........... 27 ............ 9 ..... . ..... 23 ........ . . . 23 ....... .. . . 23 . . ....... . . 23 ........ ... 23 ..... .. . ... 23 . .......... 23 ........... 23 .. . .. . .. ... 23 ..... ... ... 23 ... .... .... 23 ........... 23 .... .. ..... 23 ..... ...... 23 . . ... .... .. 23 ........... 23 ........... 23 ........... 23 31
HL2800 - NUMERICAL IN DEX _ _ _ _ _ _ _ __ _ _ _ __ _ Part No.
064315
064317
064318
064331
064335
064336
064338
064349
064352
064353
064354
064394
064395
064397
064398
064399
064402
064403
064404
064405
064406
064409
064410
064411
064412
064415
0644 17
06441 8
064419
064420
064423
064962
065 164
065165
065240
06524 1
065355
065756
065810
065820
0658 23
065829
0658 30
065904
065905
065906
066564
066565
066574
066787
066788
066789
066790
066791
066792
066793
066794
066795
32
Page No.
.. . . .. ..... 23
. .. .. .. . . .. 23
.. . ...... . . 23
........... 15
. .......... 24
....... . ... 24
.. ......... 24
........... 11
........... 11
.. ...... .. . 11
........... 11
. ....... . .. 24
.. . ...... . . 14
.... . ...... 14
.. . ...... . . 14
........ . .. 14
. . ........ . 14
..... .. .... 14
. .... ... .. . 14
.... .. ..... 14
.. ......... 14
.. . .. . ..... 14
.. .. .. ..... 14
... .. ...... 14
........... 14
........... 14
. .... . ... . . 14
.. ... . . . ... 11
. . .. ... . ... 24
. . . .... .... 14
...... . ... . 11
... .. .... .. 18
.. . ... . . .. . . 9
.. . ...... ... 9
...... .. .. . 14
.. ... ... ... 14
. .... ... .. . 17
.. . . . ..... . . 9
.. ........ . 17
...... . . . .. 11
.... .. . .... 11
. . . . .. . ... . 11
. . . ........ 11
. .. ... .... . 17
. . . .. ... .. . 17
. .... . .... . . 7
... . ... .. .. 23
. ... . .. . .. . 23
. . . .... ... . . 9
. .. . ... .. .. 20
. .. . ..... . . 20
.. . ....... . 20
... . . ... ... 20
.. .... ..... 20
..... . ..... 20
.. . .... .... 20
. ........ .. 20
.... .... ... 20
Part No.
066796
066797
066798
067137
067139
067140
067141
067145
067146
067228
067552
067559
067609
067630
067631
067638
067642
067643
067644
067645
067648
067652
067653
Q67654
067658
067660
067661
067662
067663
067664
067665
067666
067667
067668
067671
067672
967673
067674
067675
067676
067679
067681
067683
067684
067685
067686
067687
067688
067691
067692
067693
067694
067695
067698
067699
067708
067710
067711
Page No.
........... 20
........... 20
........... 24
........... 17
........... 21
........... 21
........... 21
........... 21
........... 21
........... 11
........... 15
........... 15
............ 7
............ 7
. ........... 7
............ 9
... . ........ 9
............ 9
..... .. ...... 9
............ 9
............ 9
.... . ....... 9
............ 9
............ 9
............ 9
............ 9
............ 9
............ 9
............ 9
............ 9
............ 9
............ 7
............ 9
............ 9
............ 9
............ 9
......... 9,17
.... . ....... 7
........... 13
............ 9
. .. . ..... . .. 9
........... . 9
............ 9
.... . ....... 9
............ 9
............ 9
.. . . . .... .. . 9
............ 9
............ 9
.. .. ..... .. . 9
. ........... 9
............ 7
............ 9
............ 9
............ 9
........... . 9
............ 9
.. .......... 9
Part No.
067713
067714
067716
067717
067725
067727
067728
067729
067730
067731
067732
067733
067734
067735
067738
067739
067740
067741
067746
067747
067748
067749
067750
067751
067753
067757
067760
067761
067762
067763
067764
067765
067767
067768
067769
067771
067772
067773
067774
067777
067779
067780
067781
067782
067783
067784
067785
067786
067787
067788
067789
067790
067791
067792
067793
067794
067795
067798
Page No.
........... . 9
.......... . 12
........... 12
. .......... 12
........ . .. 12
.... . . .. ... 12
. .......... 12
........... 12
........... 12
........... 12
........... 12
........... 12
..... .. .... 12
...... , .... 12
... . ..... .. 11
........... 11
........... 14
........... 14
........... 11
.......... . 11
........... 11
........... 12
............ 7
. ....... 15,30
........... 17
..... . ... 9,17
........... 17
......... .. 17
......... . . 17
........... 17
.. . ........ 17
........... 17
..... .. .... 17
........... 17
......... .. 17
........... 17
.... .. .. . .. 17
........... 19
........... 19
........... 19
........... 19
.......... . . 7
... . ...... . 19
........... 19
. . ... . . ... . 19
. . . ... . ... . 19
........... 19
........... 19
. . .. . . .... . 19
... .. . . .... 19
........ .. . 19
........... 19
........... 19
........... 19
., .......... 7
............ 7
........... 14
. . .......... 7
Part No.
067804
067819
067821
067822
067823
067831
067834
067839
067840
067841
067845
067856
067875
067882
067884
067885
067888
067917
067920
067921
067977
067978
067979
067980
067981
068035
068039
068040
068041
068218
068223
068226
068228
068245
068299
068303
068304
068305
068319
068336
068337
068339
068484
068488
068628
068647
068648
068649
068650
068651
068652
068653
068654
068655
068656
068657
068658
068659
Page No.
. . ... . .... .. 7 .. ... ... . ... 7 . . . ... . . .. . 18 .. . . .. . . ... 18 . .. . . .. .. 9,18 ....... .... 18 . .. .. .. . .. . 18 ... . . .. . . . . . 9 . .. .... . . . .. 9 .... ....... 19 .. .. . . .... . . 9 ........... . 7 ............ 7 .. . .. .. ..... 9 ... ...... .. 18 . . . .... . ... 18 . . . ......... 7 .......... . 11 ......... . . 11 . ... .. ..... 11 ..... .. .. .. 12 . . ..... . . . . 17 ., ... . ...... 7 . . . . ........ 7 .... . ....... 7 .. . .... .. .. . 7 ...... .. .. .. 7 ... . . . ..... 19 . .. . ... . . .. 19 ..... . . .. . .. 9 . .. ........ 17 ... .. ... . .. 30 ..... . .. . . . 17 .. .. .. . . ... 30 . ... .. .. . . . 13 ... .. . . ... . 13 . .. . . ... ... 13 . .. ...... . . 13 . .. . .. ..... 18 .. . . . . . ..... 9 . ...... . . . . . 9 ...... ... .. 18 .. , ... .. . .. . 9 .... ... . . .. 13 . .. . . . . .... 18 . . . . .... . ... 7 ., .. . .. .. . .. 7 . .. .. . . .... . 7 . . . ... . . .. . . 7 ...... . . .... 7 ............ 7 .... . . ...... 7 ........... . 7 . . ..... . ... . 7 ....... .. .. . 7 ........ . .. . 7 .... .. ... ... 7 . .. .... . ... . 7 _ _ _ _ _ _ _ _ _ _ _ _ _ __
Part No.
068661
068663
068664
068665
068667
068668
068669
068670
068678
068960
069028
069194
069226
069229
069236
069248
069276
069294
069296
069306
069367
069474
069475
069752
069806
Page No.
.... .. ..... 13 .. ......... 13 ........... 18 .. . ........ 17 ........... 17 ........... 17 ..... . ..... 17 ............ 9 ... . .... . ... 9 .......... 7,9 ........... 19 ........... 17 ........... II .. .... . .. .. 30 ........... 30 ........... 21 . .......... 18 . ... ....... 30 . .. .. .. .. ... 7 ....... . ... II ........... II ........... II ....... .... II ........... II .... ....... 12 070000
071116 ........... 12 500000 520021 ........... II 520022 ........... II 520046 . . . . ....... 14 520048 ........... 14 520054 ........... II 520055 ........... II 520066 ........... 12 520138 ........... 14 520153 ........ 11,12 580006 ........ . .. 20 580013 ........... 20 580014 ........... 20 580015 ........... 20 580030 ...... . .... 20 580033 ........... 20 580039 ........... 20 600000 602075 ....... . ...
602076 .... .. .....
602078 .. .. .......
602080 ...........
602081 ...........
602082 .. .........
602083 ...........
602084 ...........
602085 . . .........
602086 ...........
602088 ...........
602089 ...........
602090 ...........
Part No.
602091
602092
602094
602095
602096
602097
602099
602100
602101
602102
602103
602104
602lO8
602109
6021lO
602111
602112
602113
602114
602115
602118
602120
602121
602123
602423
602424
602425
602426
602427
602428
602429
602431
602432
602433
6600lO
660017
660018
660038
660043
660064
660076
660091
HL2800 - NUMERICAL INDEX Page No.
........... 24 . . .. . ...... 24 ........... 24 .. ...... . .. 24 ........... 24 . .. ........ 24 ........... 24 ...... . ... . 24 ........... 24 .. . ... .. ... 24 ....... . . . . 24 ........... 24 ........... 24 . . ......... 24 ........... 24 ........ ... 24 .. . ........ 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 ........... 24 .. . ........ 24 .. . ........ 24 ........... 24 ........... 17 ......... 9,19 ............ 9 ........... 17 ........... 19 ........... 17 ........ ... 17 .. .. ........ 7 800000 801382 ........... 29 801788 ........... 30 24 24 24 24 24 24 24 24 24 24 24 24 24 33
34
35 FARM EQUIPMENT GE HL COMPAN Y
902407/3C1P380
\NEST BEND, \NISCDNSIN 53095 U.S.A.
Printed in U.S.A.

Skid Loader - Hawkins Equipment

Transcription

Similar documents

2100 Series - BG Distribution

Skid Loader - Hawkins Equipment