Skid Loader - Hawkins Equipment

Transcription

6625
Skid Loader
Form No.
907286
®
SN 7605 and Later
Equipped with Perkins 204-30 Engine
SERVICE PARTS MANUAL
Introduction
All parts should be obtained from or ordered through
your GEHL Dealer. When ordering service parts,
specify the correct part number, full description,
quantity required, the unit model number and serial
number.
NOTE: The following abbreviations may be used
herein:
AR . . . . . . . . As Required
ALT . . . . . . . Alternate
ASSD . . . . . . Assembled
The model and serial numbers for this unit are on a decal
located inside the right chassis riser, between the lift
arm and lift cylinder. “Right” and “Left” are determined
from a position sitting on the seat and facing forward.
ASSY . . . . . . Assembly
GEHL® Company reserves the right to make changes or
improvements in the design or construction of any part
of the unit without incurring the obligation to install
such changes on any previously delivered units.
FHSCS . . . . . Flat Head Slotted Counter Sunk
NOTE: On original tire replacement, company
policy prohibits the sale of replacement tires for all
GEHL machinery. Replacement wheel sets are
available and tire size information is called out with
the wheel sets to facilitate replacement tire
selection. ALL REPLACEMENT TIRES MUST BE
PURCHASED LOCALLY.
HYD. . . . . . . Hydraulic
NOTE: Replacement batteries are not provided
by the GEHL Company. For battery specifications,
refer to the pages titled “Battery & Engine Electrial
Wiring." ALL REPLACEMENT BATTERIES MUST
BE PURCHASED LOCALLY.
CB . . . . . . . . Carriage Bolt
CS . . . . . . . . Cap Screw
HFLS . . . . . . Hex Flange Serrated
HWHTC. . . . . Hex Washer Head Thread Cut
ID . . . . . . . . Inside Diameter
INCL . . . . . . Included
JN . . . . . . . . Jam Nut
L . . . . . . . . . Lock Washer
LH . . . . . . . . Left Hand
LN . . . . . . . . Lock Nut
N. . . . . . . . . Nut (Hex Head)
NF . . . . . . . . National Fine (Thread)
Refer to the abbreviations table located on this page for
the various fastener descriptions. Standard attaching
hardware torque values are also provided on the inside
back cover.
NILN . . . . . . Nylon Insert Lock Nut
Items shown in the parts list that do not have part
numbers are shown for reference purposes only and are
NOT available for purchase.
REF . . . . . . . Reference
Dimensions are in inches unless otherwise specified.
All cap screws or bolts are grade 5, cadmium or zinc
plated; hexagon nuts for grade 5 screws or bolts are
grade B; hexagon nuts for other screws or bolts are
grade A, unless otherwise specified.
Refer to the Operator’s Manual for additional
information regarding GEHL attachments and
accessories.
P . . . . . . . . . Plain Washer
PKG . . . . . . . Package
RHMS . . . . . . Round Head Machine Screw
SHCS . . . . . . Socket Head Cap Screw
SHSS . . . . . . Socket Head Set Screw
SUPT . . . . . . Support
TFS . . . . . . . Thread Forming Screw
THD . . . . . . . Thread
THMS . . . . . . Truss Head Machine Screw
UNF . . . . . . . Unified National Coarse
Table of Contents
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . inside front cover
DECAL LOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
MAIN LOADER COMPONENTS
CHASSIS & ACCESS COVERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
LIFT ARM & GEHL QUICK-TACH™ SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
GRILLE & FUEL TANK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
AXLES, DRIVE CHAINS & RELATED COMPONENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
HYDROSTATIC SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
HYDRAULICS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
LIFT/TILT HYDRAULICS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
AUXILIARY HYDRAULICS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
FRAME MOUNTED FRONT HYDRAULICS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
HIGH FLOW HYDRAULICS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
DIESEL ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
AIR CLEANER & MUFFLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
RADIATOR & OIL COOLER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
TANDEM PUMP CONTROLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
THROTTLE CONTROLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
TRACTION CONTROLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
LIFT/TILT CONTROLS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
HAND BRAKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
ROPS, SEAT & ENGINE COVER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
RESTRAINT BAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
SOUND DEADENING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
INSTRUMENT PANEL, WIRING & COMPONENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
STANDARD LIGHTS, WIRING & COMPONENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
BATTERY & ENGINE ELECTRICAL WIRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
HYDRAULIC COMPONENTS
LIFT CYLINDER. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
TILT CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
GRAPPLE CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
PLANETARY GEARCASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
BOOST CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
DRIVE MOTOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
TANDEM PUMP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
SINGLE GEAR PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
DUAL GEAR PUMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
MAIN CONTROL VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
DIFFERENTIAL RELIEF VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
SELF-LEVELING VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
SOLENOID VALVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
ATTACHMENTS
UTILITY AND LIGHT MATERIAL BUCKETS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
68 INCH DIRT AND CONSTRUCTION BUCKET . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75
UTILITY FORK. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
68 INCH INDUSTRIAL BUCKET AND GRAPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
65 & 68 INCH INDUSTRIAL BUCKET AND GRAPPLE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
PALLET FORKS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
UTILITY GRAPPLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
INDEX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
O-RING TABLE, COUPLING & ADAPTER TORQUE TABLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
TORQUE SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . inside back cover
SL6625 - DECALS
DECAL LOCATIONS
GENERAL INFORMATION
NEW DECAL APPLICATION
Surfaces MUST be free from dirt, dust, grease and other
foreign material before applying the new decal. To
apply a solid-formed decal, remove the smaller portion
of the decal backing paper and apply this part of the
exposed adhesive backing to the clean surface while
maintaining proper position and alignment. Slowly peel
off the other portion of the backing paper while
applying hand pressure to smooth-out the decal surface.
CAUTION
ALWAYS follow safety precautions on decals.
Replace decals if they become damaged or if
the unit is repainted. If repainting, BE SURE
that all applicable decals are affixed in their
proper locations.
PAINT FINISH
Decal location information is provided to assist in the
proper selection and application of new decals, in the
event the original decals become damaged or the
machine is repainted.
Use the following list to order paint for refinishing:
For correct replacement of decals, compare the location
photographs to your machine BEFORE starting to
refinish the unit. Check-off each required decal using
the illustration reference number to find the part
number, description and quantity in the list. Refer to the
appropriate illustration for replacement locations.
906213
One Gal. Yellow
906323
One Qt. Charcoal Grey
906317
One Gal. Charcoal Grey
906214
6 (12 oz. Spray Cans) Yellow
906318
6 (12 oz. Spray Cans) Grey
NOTE: Refer to the SAFETY chapter of the
Operator’s Manual for the specific information
provided on all of the various safety decals.
907286/AP0199
1
PRINTED IN U.S.A.
SL6625 - DECALS
DECAL LIST
Decals may be purchased individually or in kit form.
This listing is repeated on each decal page for your
convenience.
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
Part
No.
Description
122958
056859
067493
072794
072797
072798
072853
072854
073075
073076
073458
079362
088790
091033
091035
091050
093202
073366
093367
093474
093477
093479
093483
093484
093506
094951
121030
122289
122432
122616
122718
123378
123379
123380
123381
123598
123912
127275
127276
129267
Decal Kit
Coolant Mixture
Red Reflector Strip
Hydraulic Oil Symbol
Diesel Fuel Symbol
Coolant Under Pressure
Lift/Tilt Lever Operation1
Traction Lever Operation1
Slow-Fast (Rabbit-Turtle) Symbol
Brake Operation
Non-Skid Strip
Hydraulic Oil Level
Auxiliary Hydraulics Operation1
WARNING - Jump Starting Loader
DANGER - Lift Arm Raised
DANGER - Rotating Component
DANGER - Avoid Electrical Contact
IMPORTANT- Locate Manual Here
WARNING - Owner’s Responsibility
WARNING-General Safety Precautions
WARNING-Overhead Guard Safety Pin
WARNING - Carry Load Low
DANGER - Heating Unit Grounding
Operating Capacities
Made in U.S.A
Non-Skid Strip
GEHL - On Grille
GEHL - On Liftarm Front
GEHL - On Vertical Riser
WARNING - Quick-Tach Locking Pin
Forward-Reverse Lever2
Forward-Reverse Auxiliary Lever2
Lift Pedal Operation2
Tilt Pedal Operation2
Dual Pump Switch
WARNINGS
Model Identification (SL6625SX)
Model Identification (SL6625DX)
Service Guide
10
14
28
13
23
38
4
2
27
2
37
29
1
T-Bar Models Only
2
Hand/Foot Models Only
PRINTED IN U.S.A.
2
907286/AP0199
SL6625 - DECALS
DECAL LIST
convenience.
10
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
26
36
22
21
24
12
30
25
15
1
38
1
2
Part
No.
Description
122958
056859
067493
072794
072797
072798
072853
072854
073075
073076
073458
079362
088790
091033
091035
091050
093202
073366
093367
093474
093477
093479
093483
093484
093506
094951
121030
122289
122432
122616
122718
123378
123379
123380
123381
123598
123912
127275
127276
129267
Decal Kit
Coolant Mixture
Red Reflector Strip
Diesel Fuel Symbol
Brake Operation
Non-Skid Strip
Hydraulic Oil Level
Made in U.S.A
Non-Skid Strip
GEHL - On Grille
Dual Pump Switch
WARNINGS
Service Guide
T-Bar Models Only
5
907286/AP0199
3
PRINTED IN U.S.A.
SL6625 - DECALS
DECAL LIST
convenience.
Ref
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
1
2
Part
No.
Description
122958
056859
067493
072794
072797
072798
072853
072854
073075
073076
073458
079362
088790
091033
091035
091050
093202
073366
093367
093474
093477
093479
093483
093484
093506
094951
121030
122289
122432
122616
122718
123378
123379
123380
123381
123598
123912
127275
127276
129267
Decal Kit
Coolant Mixture
Red Reflector Strip
Diesel Fuel Symbol
Brake Operation
Non-Skid Strip
Hydraulic Oil Level
Made in U.S.A
Non-Skid Strip
GEHL - On Grille
Dual Pump Switch
WARNINGS
Service Guide
3
11
20
17
8
35
6
32
34
(not shown)
16
19
T-Bar Models Only
18
7
31
9
33
(not shown)
PRINTED IN U.S.A.
4
907286/AP0199
SL6625 - CHASSIS & ACCESS COVERS
14
16
13
15
17
12
4
Before SN8447
5
Hand/Foot
T-Bar
6
7
3
2
9
8
25
1
10
11
18
19
24
26
18
23
20
21
22
907286/AP0199
5
PRINTED IN U.S.A.
SL6625 - CHASSIS & ACCESS COVERS
Ref.
No.
Part
No.
Description
057569
130006a
130021a
650934
128591
PLUG/PIPE MAGNETIC
GAUGE/OIL LEVEL
COVER/OIL RESERVOIR
HWHTCS 3/8 X 1
BREATHER
1
1
1
8
1
5
6
7
8
660046
660027
650916
127510
650487
BUSHING/HEX REDUCER 1/2-3/8
COUPLING/PIPE 1/2
NIPPLE/PIPE 1/2 X 2-1/2
COVER/LEFT
CS 5/16 X 1 (P,L)
1
1
1
1
2
9
127572
651168
128426
650545
127486
PLATE/PUMP COVER ASSEMBLY
HWHTCS 3/8 X 3/4
PLATE/FLOOR LOWER RIGHT
CS 5/16 X 1-1/4 (2P, NILN)
PLATE/FLOOR LOWER LEFT
1
2
1
4
1
650545
096236b
650934
123964b
127722
CS 5/16 X 1-1/4 (2P, NILN)
WINDOW/OIL LEVEL
HWHTCS 3/8 X 1
COVER/HYDRAULIC TANK
COVER/RIGHT
4
1
8
1
1
650487
127571
650487
067847
127509
CS 5/16 X 1 (P, L)
FLOOR ASSEMBLY
CS 5/16 X 1 (P, L)
3/8 NILN (P)
COVER/RIGHT
2
1
4
2
1
650487
127570
650487
067487
046022
CS 5/16 X 1 (P, L)
COVER/FOOT CONTROLS
CS 5/16 X 1 (P, L)
3/8 NILN (P)
BOLT/WHEEL
2
1
2
2
40
128909
079167
079368
650495
079369
WASHER 0.62 X 0.179
WASHER 0.62 X 0.105 (TO BE USED ONLY IN POSITION SHOWN, BOTH SIDES)
COVER/BOTTOM REAR
CS 1/2 X 1-1/4 (P, L)
COVER/BOTTOM FRONT
38
2
1
1
1
650495
075308
650448
080072
127342
CS 1/2 X 1-1/4 (P, L)
STRIP/BOLT
CS 1/4 X 3/4 (NILN)
FLAP/RUBBER
CAP/HYDRAULIC RESERVOIR
1
1
5
1
1
078595
651168
COVER/ACCESS
HWHTCS 3/8 X 3/4
2
24
1
2
3
4
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
Quantity
a) SN8447 and later.
b) Before SN8447.
PRINTED IN U.S.A.
6
907286/AP0199
SL6625 - LIFT ARM & GEHL QUICK-TACH™ SYSTEM
3
2
1
4
25
26
5
6
7
9
10
12
8
19
11
15
20
16
15
17
21
22
23
13
24
14
24
18
Before SN7945
14
907286/AP0199
7
PRINTED IN U.S.A.
SL6625 - LIFT ARM & GEHL QUICK-TACH™ SYSTEM
Ref.
No.
Part
No.
Description
127533
570005
078981
650733
079204
LIFT/ARM ASSEMBLY (INCLUDES ITEMS 10 & 3)
FITTING/GREASE
PIN/PIVOT
CS 5/16 X 2-1/2 (NILN)
BUSHING/LIFT ARM
1
2
2
2
8
067888
089079a
064861b
123826a
079205b
GROMMET
PIN/KLIK
PIN/KLIK
ARM/SAFETY ASSEMBLY
ARM/SAFETY ASSEMBLY
1
1
1
1
1
092576
9H240b
570014
079279
650650
092577
STOP/LIFT ARM
SCREW/CAP
FITTING/GREASE
PIN/ATTACHMENT
CS 1/2 X 3-1/2
BUSHING/LIFT ARM
4
2
2
2
2
2
079142b
655016
079148b
651017
079131b
ROD/SPRING ASSEMBLY
PIN/COTTER 3/16 X 1
HANDLE/ASSEMBLY
HHCS 3/4 X 3-3/4 (NILN)
ATTACHMENT/ASSEMBLY
2
2
1
1
1
15
16
17
079022
650733
H8049
073776b
079147b
PIN/TILT CYLINDER
CS 5/16 X 2-1/2 (NILN)
SPRING/STALK GUIDE
WASHER
PIN/ATTACHING
2
2
2
2
2
18
19
20
21
650850
128367a
128368a
121707a
114883a
CS 1/2 X 2-3/4 (NILN,4P)
QUICK-TACH ™ WELDMENT
HANDLE/ASSEMBLY
LINK/PIN LATCH
PIN/ATTACHMENT
2
1
1
2
2
22
23
24
25
26
128584a
570002a
065054a
087854
074860
CAP/GREASE
ZERK/GREASE
PIN/ROLL
PAD/ARM BRACE
STEM/RUBBER
2
2
2
1
1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Quantity
b) Before SN7945
PRINTED IN U.S.A.
8
907286/AP0199
SL6625 - GRILLE & FUEL TANK
15
30
19
1
17
31
2
32
33
20
3
29
25
27
18
Before SN7977
29
31
15
5
Before SN7684
6
9
8
4
20
7
10
19
12
17
22
23
24
11
18
28
21
13
12
16
22
14
907286/AP0199
9
26
PRINTED IN U.S.A.
SL6625 - GRILLE & FUEL TANK
Ref.
No.
Part
No.
Description
1
2
3
4
079483
079482
061166
128622a
080534b
FLANGE/TANK
ADAPTER/TANK
CLAMP/HOSE
TANK/ASSEMBLY
TANK/ASSEMBLY
1
1
1
1
1
5
073115
650293
079339
650704
078056
GUARD/SPILL
TFS #10 X 3/8
BRACE/TANK
CB 3/8 X 1
3/8 FLANGED LOCK NUT
1
2
1
1
1
7
8
9
10
121008
079335
079336
089042
651312
FITTING/BRASS COMPRESSION
TUBE/RETURN
TUBE/SUCTION
SENDER/FUEL
THMS #10-24 X 1/2
2
1
1
1
5
11
12
13
072343
087852
079171
650486
079170
GASKET/FUEL SENDER
CLAMP/HOSE
RETAINER/TANK
CS 5/16 X 3/4 (NILN)
BASE/TANK
1
3
1
2
1
123661a
079416b
650517
075237
088141
CAP/LOCKING (INCLUDES 080306 KEY)
CAP/LOCKING (INCLUDES 080306 KEY)
PLUG/HEX SOCKET HEAD 1/4 PIPE
BUSHING/PIVOT
ROD/LATCH
1
1
1
3
1
088139
650835
062282
088140c
650706
HANDLE/LATCH
CS 1/4 X 1 (P, NILN)
GRIP
PIN/LATCH
CS 1/4 X 2-1/4 (2P, NILN)
1
1
1
2
2
24
088035
650495
127659
650487
128091d
PIN/PIVOT
CS 1/2 X 1-1/4 (P, L)
PLATE COVER/LOCK
CS 5/16 X 1 (2P, NILN)
GRILLE/ASSEMBLY
2
2
1
1
1
25
26
27
28
29
056937
128048
114665d
R13247c
079310d
WASHER
PLATE/ADJUSTMENT
SPRING/COMPRESSION
SPRING/COMPRESSION
PIN/LATCH
1
1
1
1
2
32
650706
054842d
079306d
650416
047269d
CS 14 X 2-1/4 (2P,NILN)
PIN/CLEVIS
TUBE/SPACER
HHCS 3/4 X 2-1/2 (NILN)
SOCKET/MOUNTING
2
1
2
2
1
33
650486
127512d
CS 5/16 X 3/4 (NILN)
GRILLE/ASSEMBLY
1
1
6
14
15
16
17
18
19
20
21
22
23
30
31
Quantity
b) Before SN7977
c) SN7684 and later.
d) Before SN7684.
PRINTED IN U.S.A.
10
907286/AP0199
SL6625 - AXLES, DRIVE CHAINS & RELATED COMPONENTS
10
11
1
19
12
2
3
4
18
29
6
13
7
5
8
20
17
4
14
9
7
15
10
11
13
14 15
3
8
17
14
12
13
9
11
28
21
18
23
16
11
21
19
20
3
4
26
7
8
9
22
23
25
24
907286/AP0199
11
PRINTED IN U.S.A.
SL6625 - AXLES, DRIVE CHAINS & RELATED COMPONENTS
Ref.
No.
Part
No.
Description
078961b
651211
078962
078945
078946
GEARCASE/PLANETARY ASSEMBLY
CS 3/8 NF X 3-1/2 GR8 (L)
RING/RETAINING
BEARING/CONE
BEARING/CUP
2
24
2
6
6
651330a
088470
651085
064373
078943
PLUG/PIPE 3/8 HEX
ADAPTER/PLANETARY
CS 1/2 NF X 1-3/4 GR8
1/2 NF - NILN
BEARING/CUP
1
2
22
22
6
8
9
10
11
12
078944
078947
078959
078958
078953
BEARING/CONE
SEAL/OIL
RETAINER/ASSEMBLY
SHIM
TAKEUP
6
6
4
AR
4
13
14
655018
650572
653119
041885
041884
PIN/COTTER 3/16 X 1-1/4
HHCS /58 X 2-3/4 (L)
NUT/SLOTTED 3/4 NF
CONE/BEARING
BEARING/CUP
4
4
4
8
8
078955
078952
650354
650847
078949
SPROCKET/IDLER ASSEMBLY 14T
TAKEUP/ASSEMBLY
CS 5/8 X 4-1/2 (L)
SQHSS 5/8 X 4 (JN)
WASHER
4
4
4
4
4
127560
078948
078612
570002
128988
SPROCKET/ASSEMBLY 48T
WASHER/SHIM
ADAPTER/WHEEL
FITTING/GREASE
BOLT/WHEEL
4
AR
4
4
32
25
128993
650554
650964
131083
122978
122976
079152
AXLE/ASSEMBLY
NUT/CASTELLATED 1-1/4 NF
WHEEL/15 X 6
WHEEL/15 X 13
WHEEL/16.5 X 9.75
NUT/WHEEL
4
4
4
4
4
4
32
26
27
28
29
128507
127557c
127567
127558d
STEM/VALVE
CHAIN/ROLLER (SUPER 80H) 72 LINKS WITH CONNECTOR 129506
SHAFT/PLANETARY ASSEMBLY
CHAIN/ROLLER (SUPER 80H) 86 LINKS WITH CONNECTOR 129506
4
2
2
2
1
2
3
4
5
6
7
15
16
17
18
19
20
21
22
23
24
Quantity
b) For service, see pages titled “Hydraulic Components.”
c) Short Chain for left front and right rear.
d) Long Chain for left rear and right front.
PRINTED IN U.S.A.
12
907286/AP0199
SL6625 - HYDROSTATIC SYSTEM
1
2
5
8
1
28
31
5
1
27
30
29
24
18
23
19
16
7
10
17
11
32
20
22
15
25
11
21
11
10
6
13
12
10
26
11
4
33
14
4
10
13
4
5
3
3
13
12
9
Before SN8488
907286/AP0199
13
PRINTED IN U.S.A.
SL6625 - HYDROSTATIC SYSTEM
Ref.
No.
Part
No.
Description
1
2
3
4
5
089095
055981
067761
121684
087215
HOSE/ASSEMBLY 3/8 X 17
FITTING/TEE
ELBOW/90 DEGREE MALE
CONTROL/BOOST
4
1
2
4
2
4
1
2
4
2
6
7
8
9
650818
091059
062889
068938
091060
CS 3/8 X 3 (NILN,P)
CONNECTOR/STRAIGHT
ELBOW/90 DEGREE ADJUSTABLE
2
1
1
2
1
2
1
1
2
1
121050
121773
079034
650495
079289a
ELBOW/45 DEGREE
MOTOR/DRIVE
CS 1/2 X 1-1/4 (L)
O-RING
4
4
2
4
2
4
4
2
4
2
054783b
073411
088912
078831
650487
GASKET/MOTOR
CONNECTOR/STRAIGHT
WASHER/SPECIAL
BRACKET/ISOLATOR
CS 5/16 X 1 (NILN, 4P)
2
1
1
1
2
2
1
1
1
2
072384
650528
127482
650495
091017
ISOLATOR/RUBBER
CS 3/8 X 2 (NILN)
SUPPORT/PUMP
CS 1/2 X 1-1/4 (N)
TUBE/PUMP DRAIN
1
1
1
2
1
1
1
1
2
1
23
075503
088120
127548
068034
122083
TEE/TAPPED
PUMP/TANDEM
1/2 NILN (P)
HOSE/ASSEMBLY
1
1
1
2
1
1
1
1
2
1
24
25
26
27
28
075235
079100
127200
056088
054820
ELBOW/90 DEGREE W/3/8 NPT
FITTING/TEE
TEE/MALE RUN STRIAGHT TO 37 DEGREE
2
1
1
1
1
2
1
1
1
1
29
30
31
32
056087
079420
078921
127725
072587
CONNECTOR/MALE
COOLER/OIL
COOLER/OIL
CONNECTOR/STRAIGHT
2
1
1
1
2
1
1
1
33
057650
1
1
10
11
12
13
14
15
16
17
18
19
20
21
22
Quantity
6625SX
6625DX
b) Before SN8488.
PRINTED IN U.S.A.
14
907286/AP0199
SL6625SX - HYDRAULICS
3
5
4
7
1
2
6
8
11
10
3
13
9
12
17
18
14
6
19
15
16
20
22
22
26
23
24
25
907286/AP0199
15
PRINTED IN U.S.A.
SL6625SX - HYDRAULICS
Ref.
No.
Part
No.
Description
1
2
3
4
5
078984
088267
079106
079105
114446
BRACKET/FILTER
CONNECTOR/STRAIGHT
CAP/DUST
CHECK/PRESSURE
VALVE/RELIEF
1
1
2
1
1
6
7
8
9
10
072587
075503
088283
074830
074020
CONNECTOR/STRAIGHT
HOSE/LP 3/4 X 24
TEE/TAPPED
ELEMENT/FILTER
FILTER/RETURN HYDRAULIC OIL
2
1
1
1
1
11
12
13
14
15
055005
079109
079107
054819
074282
ELBOW/90 DEGREE
CHECK/PRESSURE
VALVE/CONTROL
CONNECTOR/STRAIGHT
CONNECTOR/TEE
1
1
1
1
1
16
17
18
19
20
079103
087030
114715
079102
056089
HOSE/ 1-1/4 X 51
TUBE/RETURN
STRAINER/SUCTION
FITTING/ELBOW
CONNECTOR/TEE
1
1
1
1
1
21
22
23
24
25
079420
127482
079289
055064
127546
HOSE/MP 3/4 X 37
SUPPORT/PUMP
O-RING
ELBOW/45 DEGREE
PUMP/GEAR SINGLE
1
1
1
1
1
26
079288
ELBOW/45 DEGREE
1
PRINTED IN U.S.A.
Quantity
6625SX
16
907286/AP0199
SL6625 - LIFT/TILT HYDRAULICS
1
36
37
7
36
5
1
36
20
5
7
3
34
7
10
2
8
11
7
14
24
13
26
25
12
7
16
11
4
7
7
9
18
17
26
33
6
36
36
19
32
9
5
20
10
21
22
32
20
26
7
7
23
30
27
35
32
8
24
28
31
31
30
11
12
29
30
28
18
29
13
26
11
16
26
14
17
907286/AP0199
17
PRINTED IN U.S.A.
SL6625 - LIFT/TILT HYDRAULICS
Ref.
No.
Part
No.
Description
1
2
3
4
5
079282
128522a
128300c
128301c
079112
HOSE/ 5/8 X 66
TUBE/VALVE-TILT RIGHT
TUBE/VALVE-TILT UPPER
TUBE/VALVE-TILT LOWER
TUBE/VALVE-SELF LEVEL
2
1
1
1
2
6
7
8
9
10
127511
054819
067761
079108
128844
TUBE/SELF-LEVEL
CONNECTOR/STRAIGHT
ELBOW/90 DEGREE
ELBOW/ 90 DEGREE
VALVE/SELF-LEVEL
1
6
1
1
1
652040
079280
078981
650547
088937
CB 5/16 X 2-1/2 (NILN)
HOSE/1/2 X 24
PIN/PIVOT
CS 5/16 X 3-1/2 (NILN)
CLAMP/TUBE
2
4
2
2
2
14
15
16
079283
075235
128868
570005
570002
TUBE/CLYLINDER REAR
ELBOW/90 DEGREE
CYLINDER/LIFT
FITTING/GREASE 90 DEGREE
FITTING/GREASE SHORT
2
1
2
2
2
17
127620
650733
079284
079121
067460
PIN/LIFT CYLINDER FRONT
CS 5/16 X 2-1/2 (NILN)
TUBE/CYLINDER FORWARD
TUBE/SELF-LEVEL TILT
FITTING/TEE
2
2
1
1
2
21
22
23
24
079120
079175
079111
129314e
122900f
TUBE/SELF-LEVEL TILT
TUBE/SOLENOID LIFT RIGHT
TUBE/VALVE SOLENOID
VALVE/SOLENOID
VALVE/SOLENOID
2
1
1
2
2
25
26
27
28
127972
072580
079122
123444
570005
TUBE/TILT CYLINDER CURL
CONNECTOR/STRAIGHT
TUBE/SOLENOID LIFT
CYLINDER/TILT
FITTING/GREASE 90 DEGREE
1
5
1
2
4
29
079022
650733
062397
123725
540020
PIN/TILT CYLINDER
CS 5/16 - 2-1/2 (NILN)
ELBOW 45 DEGREE MALE
PIN/TILT CYLINDER
RETAINING RING
2
2
4
2
2
32
33
34
35
650733
128632
122649
127971
072587
CS 5/16 X 2-1/2 (NILN)
HOSE/ 3/8 X 15
CLAMP/TUBE
TUBE/TILT CYLINDER DUMP
CONNECTOR/STRAIGHT
4
4
1
1
1
36
37
38
056089
079423b
079119d
FITTING/TEE
TUBE/VALVE TILT RIGHT
TUBE/VALVE TILT
2
1
1
11
12
13
18
19
20
30
31
Quantity
b) Before SN7956.
d) Before SN7928.
e) SN8401 and later.
f) Before SN8401.
PRINTED IN U.S.A.
18
907286/AP0199
SL6625 - AUXILIARY HYDRAULICS
10
Hand/Foot Only
7
26
6
27
18
9
7
28
31
6
3
30
2
29
7
1
6
5
14
4
13
11
12
14
16
15
T-Bar Only
17
19
20
21
18
24
23
25 18
22
21
20
18
907286/AP0199
19
PRINTED IN U.S.A.
SL6625 - AUXILIARY HYDRAULICS
Ref.
No.
Part
No.
Description
1
2
3
4
5
079417
122864
072587
079418
122865
CAP/DUST
NIPPLE/QUICK DISCONNECT
CONNECTOR/MALE 37 DEGREE
PLUG/DUST
COUPLER/QUICK DISCONNECT
1
1
1
1
1
6
7
9
10
079097
079098
650733
079244
079282
CLAMP/TUBE
PLATE/TWIN COVER
CS 5/16 X 2-1/2
TUBE/AUXILIARY HYDRAULICS
3
3
3
2
2
11
12
13
14
15
079116
079117
075235
054819
079114
TUBE/AUXLIARY LEFT REAR
TUBE/VALVE AUXILIARY
ELBOW/SWIVEL
CONNECTION/STRAIGHT
TUBE/AUXILIARY
1
1
2
2
1
16
17
082800
127345
067847
127488
650551
FITTING/ELBOW 90 DEGREE
PEDAL/AUXILIARY
1/2 NILN (P)
PIN/CLEVIS
PIN/COTTER
1
1
1
4
4
127344
650487
065164
079614
121002
SUPPORT/PEDAL
CS 5/16 X 1 (NILN,P)
YOKE/CLEVIS
CLAMP/CONDUIT
1/2 NF NILN
1
3
2
2
4
115039
650648
127360
127357
650545
CABLE
#10-32 NUT
BUSHING/PIVOT
STOP/BAR
CS 5/16 X 1-1/4 (NILN,P)
1
2
1
1
1
25
26
27
28
088254
079068
079039
054202
064840
LEVER/CONTROL
LEVER/CONTROL
ROD/CONTROL
JOINT/BALL
3/8NF NILN
1
1
1
1
1
29
30
123672
123719
650487
123668
075288
SPACER
BRACKET/DETENT
CS 5/16 X 1 (P,NILN)
TAB/ASSEMBLY
PIN/ROLL
1
1
1
1
1
18
19
20
21
22
23
24
31
PRINTED IN U.S.A.
Quantity
20
907286/AP0199
SL6625SX - FRAME MOUNTED FRONT HYDRAULICS
1
14
5
7
2
15
6
3
16
4
9
2
14
5
18
17
3
8
10
19
11
13
10
907286/AP0199
12
21
PRINTED IN U.S.A.
SL6625SX - FRAME MOUNTED FRONT HYDRAULICS
Ref.
No.
Part
No.
Description
1
2
3
4
5
087015
079115
056085
087027
056088
TUBE/RETURN
FITTING/TEE
NUT/JIC CAP 1-1/16
TUBE/AUXILIARY RETURN
FITTING/TEE
1
2
1
1
2
6
7
8
9
10
087026
079108
075173
087024
066580
TUBE/POWER BEYOND RIGHT
TUBE/RETURN RIGHT FRONT
BRACKET/TUBE RIGHT
FITTING/MALE CONNECTOR
1
1
1
1
2
11
12
13
14
15
056429
075174
087014
075235
122865
VALVE/SHUT-OFF
TUBE/RETURN LEFT FRONT
BRACKET/TUBE LEFT
1
1
1
1
1
16
17
18
19
079418
079417
122864
087028
PLUG/DUST
CAP/DUST
TUBE/POWER BEYOND LEFT
1
1
1
1
PRINTED IN U.S.A.
Quantity
6625SX
22
907286/AP0199
SL6625DX - HIGH FLOW HYDRAULICS
17
18
16
1
15
3
4
2
2
3
15
56
3
6
14
21
15
5
20
12
6
26
11
7
19
24
13
9
22
25
8
23
50
10
27
21
28
30
56
52
51
30
6
47
57
29
48
49
32
46
31
33
43
54
39
53
45
40
44
42
36
34
38
37
41
40
35
36
37
Before SN8401
907286/AP0199
23
PRINTED IN U.S.A.
SL6625DX - HIGH FLOW HYDRAULICS
Ref.
No.
Part
No.
Description
Quantity
6625DX
1
2
3
4
5
128320
128224
128335
128319
122865
COVER/LIFT ARM
TUBE/HIGH FLOW
CLAMP/1.00 DOUBLE
BRACKET/LIFT ARM REAR
COUPLER/FEMALE
1
2
1
1
1
6
7
8
9
10
054818
122864
079098
079418
079417
CONNECTOR/STRAIGHT
COUPLER/MALE
PLATE/TWIN COVER
PLUG/DUST
CAP/DUST
3
1
1
1
1
11
12
13
14
15
056104
128031
054626
128330
076147
CAP/DUST
COUPLER/QUICK MALE
CONNECTOR/STRAIGHT
TUBE/CASE DRAIN
CLAMP/HOSE
1
1
1
1
3
16
17
18
19
20
128334
127966
128333
114446
072587
HOSE/ASSEMBLY 1 X 98
HOSE/ASSEMBLY 1 X 72
VALVE/RELIEF
CONNECTOR/STRAIGHT
1
1
1
1
1
21
22
23
24
25
079106
079105
088283
127953
078984
CAP/DUST
CHECK/PRESSURE
TEE/TAPPED
CONNECTOR/STRAIGHT SWIVEL
BRACKET/FILTER
2
1
1
1
1
26
27
28
29
30
079029
127950
079109
128247
054819
ELBOW/45 DEGREE
FITTING/TEE
CHECK/PRESSURE
TUBE/RETURN
CONNECTOR/STRAIGHT
1
1
1
1
2
31
32
33
34
35
128244
128250
079103
128190
127547
FITTING/TEE
TUBE/RETURN
HOSE/1-1/4 X 51
ELBOW/45 DEGREE
GEAR PUMP/DOUBLE
1
1
1
1
1
36
37
38
39
40
055005
055064
079420
064644
129460a
ELBOW/90 DEGREE
ELBOW/45 DEGREE
HOSE/MP 3/4 X 37
CONNECTOR/STRAIGHT
VALVE/SOLENOID
2
2
1
1
1
41
42
43
44
127468b
127779
128317
056089
087843
VALVE/SOLENOID RELIEF
HOSE/ LP 3/4 X 34
TUBE/AUXILIARY
CONNECTOR/TEE
1
1
1
1
1
45
46
47
48
49
122756
088046
087837
072615
065102
FILTER/OIL ASSEMBLY
CONNECTOR/STRAIGHT
BRACKET/FILTER
ELBOW/90 DEGREE
ELBOW/45 DEGREE
1
1
1
1
1
50
51
52
53
54
127948
114715
075503
079289
127482
FILTER/ASSEMBLY
STRAINER/SUCTION
HOSE/LP 3/4 X 24
O-RING
SUPPORT/PUMP
1
1
1
1
1
55
56
57
128318
079107
079102
BRACKET/LIFT ARM FRONT
VALVE/CONTROL
FITTING/ELBOW
1
1
1
b) Before SN8401.
PRINTED IN U.S.A.
24
907286/AP0199
SL6625 - DIESEL ENGINE
39
40
35
33
36
35
34
36
4
35
36
2
41
2
38
44
37
5
Remote Oil Filter
43
6
1
3
32
30
29
42
28
8
26
7
25
10
16
31
13
27
9
11
12
26
15
14
16
18
18
20
17
18
19
18
21
22
15
22
18
23
Before SN7932
24
907286/AP0199
25
PRINTED IN U.S.A.
SL6625 - DIESEL ENGINE
Ref.
No.
Part
No.
Description
1
2
3
4
5
123832a
127389
079757
128279
080304
ENGINE/PERKINS DIESEL
FILTER/ENGINE OIL
FILTER/FUEL
BELT/FAN
ALTERNATOR
1
1
1
1
1
6
7
8
9
128179
127452
127505
124068
656181
STARTER
VALVE/OIL DRAIN
HOSE/DRAIN
SPACER/LONG
CS M10X40 (L)
1
1
1
1
1
10
124069
656186
123867
656083
123865
SPACER/SHORT
CS M10X50 (L)
MOUNT/ENGINE RIGHT REAR
CS M10X25 (L)
MOUNT/ENGINE LEFT REAR
1
1
1
4
1
656083
123860
656083
123859
656083
CS M10X25 (L)
MOUNT/ENGINE RIGHT FRONT
CS M10X25 (L)
MOUNT/ENGINE LEFT FRONT
CS M10X25 (L)
2
1
4
1
4
060039
065756
650694
087851b
062023
MOUNT/ISOLATOR
WASHER/SPECIAL
CS 5/8X2-1/2 (NILN)
TUBE/FUEL
CLAMP/HOSE
4
4
4
2
6
20
21
22
23
072601
078919
123829c
123827c
650487
HOSE/FUEL
HOSE/FUEL
ELBOW/90 DEGREE
FILTER/SEPARATOR
CS 5/16X1 (NILN)
1
2
2
1
1
24
25
123828c
127392
656188
123596
123898
ELEMENT/FILTER
PLATE/PUMP
M10X70 (L, 3/8P)
SPACER
PLATE
1
1
4
2
1
656006
123905
656006
078629
114212
HHCS M10X20 (L, 3/8P)
BRACKET/SERVO MOUNTING
CS M10X20 (L, 3/8P)
HUB/COUPLING
COUPLING/FLEXIBLE
4
1
2
1
1
33
34
114336
123509
656083
128305
127644
SHCS M10X40
DISK/FLYWHEEL
CS M10X25 (L)
GASKET/SEAL
ADAPTER/ENGINE PLATE
6
1
6
1
1
35
36
37
38
39
128261
095955
129734
129735
127640
FITTING/BARB
CLAMP/HOSE
HOSE(BLACK)
HOSE(BLUE)
PLATE/FILTER
4
4
1
1
1
42
650835
650517
128309
650487
127750
CS 1/4X1 (NILN)
PLUG/PIPE
BRACKET/OIL FILTER
CS 5/16X1 (NILN)
CLAMP/SPRING
2
2
1
1
1
43
43
129616
121491
HEATER/BLOCK
CORD/HEATER
1
1
11
12
13
14
15
16
17
18
26
27
28
29
30
31
32
40
41
Quantity
a) For Engine Components NOT included in this manual, refer to the Engine manufacturer’s parts manual.
b) Before SN 9431.
PRINTED IN U.S.A.
26
907286/AP0199
SL6625 - AIR CLEANER & MUFFLER
7
1
8
6
2
4
8
5
9
11
10
12
3
Before SN8401
13
Replaced By
Items 22 & 23
23
14
21
22
20
15
19
16
17
18
24
25
907286/AP0199
Before SN7945
27
PRINTED IN U.S.A.
SL6625 - AIR CLEANER & MUFFLER
Ref.
No.
Part
No.
Description
3
127481
650492
078912
650487
129770
SUPPORT/AIR CLEANER
CS 3/8 X 2-1/2 (8P, NILN)
BAND/MOUNTING
CS 5/16X1 (P, NILN)
CLEANER/DUAL AIR (INCLUDES ITEMS 1 TO 9)
1
4
2
4
1
4
5
6
7
8
087860
087859
129769
420-32432
078936
ELEMENT/OUTER
ELEMENT/INNER
CUP/AIR CLEANER
BAFFLE
WING NUT
1
1
1
1
2
9
10
11
12
13
091869
087982c
078914
127987
087849
CLAMP
VALVE/VACUATOR
GAUGE/RESTRICTOR
HOSE/INTAKE
CLAMP/HOSE
1
1
1
1
1
14
131560
653010
128363a
078931
127473
BAND/MUFFLER
3/8 NUT (P,L)
MUFFLER
CLAMP/MUFFLER
SPACER
1
1
1
1
4
123886
127445
650491
127428
127396
PIPE/MUFFLER
SUPPORT/MUFFLER
CS 3/8X1-1/4 (2P, NILN)
CLAMP/MUFFLER
PIPE/TAIL
1
1
1
1
1
128230b
650486
650490
128231b
650448
PLATE/HEAT SHIELD
CS 5/16X3/4 (2P, NILN)
CS 3/8X1 (2P, NILN)
BRACE/HEAT SHIELD
CS 1/4X3/4 (P, NILN)
1
2
2
1
1
123922b
133084
MUFFLER
GASKET/EXHAUST PIPE
1
1
1
2
15
16
17
18
19
20
21
22
23
24
25
Quantity
a) SN7945 and Later.
b) Before SN7945.
c) Before SN8401
PRINTED IN U.S.A.
28
907286/AP0199
SL6625 - RADIATOR & OIL COOLER
25
26
27
24
23
25
28
20
17
21
18
27
25
23
22
15
19
30
6
9
7
5
4
3
9
10
29
2
16
12
13
1
17
7
14
3
5
15
8
907286/AP0199
11
29
PRINTED IN U.S.A.
SL6625 - RADIATOR & OIL COOLER
Ref.
No.
Part
No.
Description
127525
127495
656130
088912
067847
SPACER/FAN
FAN/NYLON 17"
HHCS M8X50 (5/16L)
WASHER/SPECIAL
3/8 NILN
1
1
4
2
2
1
1
4
2
2
123986
072384
057067
127556
123987
BRACE/RADIATOR RIGHT
MOUNT/IRUBBER
PLUG
SEAL/SHROUD
BRACE/RADIATOR LEFT
1
2
1
2
1
1
2
1
2
1
9
10
11
12
055030
124015
123946
127652
650490
CLAMP/HOSE
HOSE/LOWER RADIATOR
HOSE/UPPER RADIATOR
SUPPORT/RADIATOR
CS 3/8X1 (P, NILN)
4
1
1
1
4
4
1
1
1
4
13
127492
650533
127491
650533
058615
MOUNT/RADIATOR RIGHT
CS 3/8X1-1/2 (2P, NILN)
MOUNT/RADIATOR LEFT
CS 3/8X1-1/2 (2P, NILN)
CLAMP/HOSE
1
2
1
2
3
1
2
1
2
3
16
17
18
19
127505
129346
079010
129059
650485
HOSE/DRAIN
DRAIN/COCK
CAP/RADIATOR
SUPPORT/COOLER
CS 5/16X5/8 (L, P)
1
2
1
1
2
1
2
1
1
2
20
128816
650485
128815
650485
078921
PLATE/RADIATOR
CS 5/16X5/8 (L, P)
PLATE/HINGE
CS 5/16X5/8 (L, P)
COOLER/OIL
1
2
1
2
1
1
2
1
2
-
127725
078922
650449
127497
127496
COOLER/OIL
MOUNT/ELASTOMER
CS 1/4X2-1/2 (2P, NILN)
SEAL/SHROUD
SEAL/SHROUD
4
4
1
1
1
4
4
1
1
128806
129418
129120
651312
124090
SHROUD/COOLER
SEAL/SHROUD
LATCH/FLEXIBLE
THMS #10-24X1/2 (L)
SHROUD/FAN 17"
1
2
1
3
1
1
2
1
3
1
650485
128182
068034
CS 5/16X5/8 (L, P)
RADIATOR (INCLUDES ITEMS 18 & 20)
1/2 NILN (P)
4
1
2
4
1
2
1
2
3
4
5
6
7
8
14
15
21
22
23
24
25
26
27
28
29
30
PRINTED IN U.S.A.
Quantity
6625SX
6625DX
30
907286/AP0199
SL6625 - TANDEM PUMP CONTROLS
7
12
7
5
3
9
11
2
10
6
3
8
2
5
1
4
3
2
11
10
3
9
907286/AP0199
31
PRINTED IN U.S.A.
SL6625 - TANDEM PUMP CONTROLS
Ref.
No.
Part.
No.
Description
130336a
650835
087969b
650835
128113
PIVOT/ASSEMBLY
CS 1/4X1 (L)
PIVOT/ASSEMBLY
CS 1/4X1 (L)
WASHER
1
4
1
4
1
129376a
129376b
131202a
650484
087972b
BUSHING
BUSHING
LEVER/ASSEMBLY (INCLUDES BEARINGS)
CS 5/16X1/2 (L)
CRANK
5
6
1
1
1
7
650484
087974
087975
650577
079039
CS 5/16X1/2 (L)
JOURNAL/PIVOT
LINK
CS 5/16X1 1/2 (NILN)
END/ROD
1
2
1
2
4
8
9
10
650818
653039
073678
045026
129375
CS 3/8X3 (NILN)
3/8 NF JAM NUT
WASHER
RING/RETAINING
BUSHING/ISOLATOR
2
4
1
2
2
127465
650493
651059
123905
656006
ARM/PUMP
CS 3/8X2 3/4 (NILN)
KEY/WOODRUFF 1/4X3/4
BRACKET/SERVO
HHCS M10X20 (3/8P)
2
2
2
1
2
1
2
3
4
5
6
11
12
656010
656103
Quantity
HHCS M10X40 (3/8P)
M10 LOCKWASHER
2
4
b) Before SN8514.
PRINTED IN U.S.A.
32
907286/AP0199
SL6625 - THROTTLE CONTROLS
8
7
5
6
4
1
3
2
6
9
8
10
16
18
11
14
12
13
17
Hand/Foot Only
8
7
1
6
4
2
3
8
15
6
16
907286/AP0199
33
PRINTED IN U.S.A.
SL6625 - THROTTLE CONTROLS
Ref.
No.
Part
No.
Description
062282
127320
124080
070613
079210
GRIP
HANDLE/THROTTLE
STUD
SPRING/EXTENSION
CABLE/THROTTLE
1
1
1
1
1
650648
065163
650387
075042
079214
#10-32 NUT
CLAMP
RHMS #10-32X1/2 (N,L)
YOKE/CLEVIS
BUSHING
2
1
2
2
1
10
127488
650551
127840
650487
057490
PIN/CLEVIS
PIN/COTTER
BRACKET/THROTTLE
CS 5/16X1 (P, NILN)
SPACER
2
2
1
2
1
11
12
13
14
068034
079341
127716
064238
088199
1/2 NILN (2P)
LEVER/ARM
PIN/SPRING
YOKE/CLEVIS
ROD/THROTTLE
1
1
1
1
1
655001
123651a
068034
124078
650579
PIN/COTTER (2P)
BRACKET/THROTTLE
1/2 NILN
WASHER/BELLEVILLE
CS 3/8X1-3/4 (NILN)
2
1
1
3
1
127220
067847
079212
068034
PEDAL/THROTTLE
3/8 NILN
STRIP/SLIP
1/2 NILN
1
1
1
2
1
2
3
4
5
6
7
8
9
15
16
17
18
Quantity
a) Units equipped with Hand/Foot controls.
PRINTED IN U.S.A.
34
907286/AP0199
SL6625 - TRACTION CONTROLS (T-BAR)
SN8004 and Later
26
25
24
23
24
21
15
16
1
17
20
6
18
16
18
17
19
13
13
18
6
16
2
9
3
16
18
8
6
5
12 6
4
15
14
11
10
9
6
5
7
22
8
907286/AP0199
35
PRINTED IN U.S.A.
SL6625 - TRACTION CONTROLS (T-BAR)
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
Part
No.
Description
088946
050270
074093
121578
650486
HANDLE/CONTROL
PIN/ROLL
BOOT/RUBBER
BRACKET/TRUNNION RIGHT
CS 5/16X3/4 (NILN)
063718
650733
065057
056937
131848
SPACER
CS 5/16X2 1/2 (NILN)
BEARING/NEEDLE
WASHER
LEVER/PIVOT ASSY
075288
079216
651062
060505
123280
PIN/ROLL
END/ROD
5/16NF NUT (P,L)
BEARING/NEEDLE
BRACKET/TRUNNION LEFT
1
4
4
2
1
650486
123722
653039
060508
076002
CS 5/16X3/4 (NILN)
ROD/TAKE UP
5/16NF JAM NUT
TRUNNION
ZERK/GREASE
1
2
4
1
1
127360
088239
075288
128892a
650487
BUSHING
ARM/PIVOT
PIN/ROLL
BRACKET/BEARING
CS 5/16X1 (NILN)
AR
1
1
2
4
078990b
650487
128316
127480
650545
BRACKET/BEARING
CS 5/16X1 (NILN)
BUSHING/PIVOT
LINK/CONTROL
CS 5/16X1 1/4 (NILN)
2
4
4
2
4
079042
650898
653036
089092
089091
JOINT/BALL
CS 5/16NF X 1(L,P)
5/16NF JAM NUT
TUBE/TORSION ASSEMBLY
LINK/OUTPUT ASSEMBLY
2
2
2
1
1
075288
088242
054202
064840
122095
PIN/ROLL
SHAFT/PIVOT
JOINT/BALL
3/8NF NILN
ABSORBER/SHOCK
1
1
2
2
2
650552
079039
650818
123601
123420
3/8NF JAM NUT
JOINT/BALL
CS 3/8X3 (NILN)
SPACER
BRACKET/SHOCK MOUNT
4
2
1
2
1
656010
656103
Quantity
1
1
1
1
2
1
1
2
AR
1
CS M10X40 (3/8P)
M10 LOCK WASHER
2
2
a) SN8004 and Later.
b) Before SN8004.
PRINTED IN U.S.A.
36
907286/AP0199
SL6625 - TRACTION CONTROLS (HAND/FOOT)
20
28
20
27
20
25
16
6
17
18
1
19
24
13
6
18
6
13
9
15
2
19
23
21
3
11
6
18
22
13
17
21
5
12
6
13
11
4
16
6
5
9
6
1
10
15
7
26
2
9
3
11
14
11
4
6
8
13
10
8
907286/AP0199
37
PRINTED IN U.S.A.
SL6625 - TRACTION CONTROLS (HAND/FOOT)
Ref.
No.
Part
No.
Description
122484
050270
074093
121578
650486
HANDLE/CONTROL
PIN/ROLL
BOOT/RUBBER
CS 5/16 X 3/4 (NILN)
4
5
6
7
063719
065057
056937
123668
075288
SPACER
BEARING/NEEDLE
WASHER
TAB ASSEMBLY
PIN/ROLL
8
9
123672
079216
651062
123280
650486
SPACER
END/ROD
5/16NF NUT (P,L)
CS 5/16 X 3/4 (NILN)
2
3
3
2
4
060505
060508
076002
079042
650898
BEARING/NEEDLE
TRUNNION
ZERK/GREASE
JOINT/BALL
CS 5/16 NF X 1 (NILN)
4
1
1
5
2
123667
076002
075288
123722
653036
TRUNNION ASSEMBLY
ZERK/GREASE
PIN/ROLL
ROD/TAKE UP
5/16NF JAM NUT
1
1
1
2
4
088239
075288
128892a
650487
078990b
ARM/PIVOT
PIN/ROLL
BRACKET/BEARING
CS 5/16 X 1 (NILN)
BRACKET/BEARING
2
2
2
4
2
650487
128316
127480
650545
079042
CS 5/16 X 1 (NILN)
BUSHING/PIVOT
LINK/CONTROL
CS 5/16 X 1-1/4 (NILN)
JOINT/BALL
4
4
2
4
4
653036
127360
089092
089091
075288
5/16 NF JAM NUT
BUSHING
TUBE/TORSION ASSEMBLY
LINK/OUTPUT ASSEMBLY
PIN/ROLL
25
26
27
075287
075288
123637
113472
122095
HUB/PIVOT
PIN/ROLL
SHAFT/PIVOT
NUT/SPRING
ABSORBER/SHOCK
1
1
1
4
2
28
650552
123601
3/8 NF JAM NUT
SPACER
4
2
1
2
3
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Quantity
2
1
2
2
4
2
2
AR
1
1
2
AR
1
1
1
b) Before SN8004.
PRINTED IN U.S.A.
38
907286/AP0199
SL6625 - LIFT/TILT CONTROLS (T-BAR)
1
2
17
3
3
15
14
4
7
15
5
18
6
16
8
4
8
13
9
12
11
10
907286/AP0199
39
PRINTED IN U.S.A.
SL6625 - LIFT/TILT CONTROLS (T-BAR)
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Part
No.
Quantity
088946
050270
074093
056937
065057
HANDLE/CONTROL
PIN/ROLL
BOOT/RUBBER
WASHER
BEARING/NEEDLE
123280
650486
127502
653039
079068
CS 5/16X3/4 (NILN)
ROD/LIFT CONTROL
3/8NF JAM NUT
ARM/TILT CONTROL
1
2
1
1
1
127488
650551
127573
653039
054202
PIN/CLEVIS
PIN/COTTER
ROD/TILT CONTROL
3/8NF JAM NUT
JOINT/BALL
4
4
1
1
1
064840
079039
067847
074868
088249
3/8NF NILN
JOINT/BALL
3/8 NILN
SPACER
TAB/TILT
1
1
1
1
1
075288
060508
076002
060505
063718
PIN/ROLL
TRUNNION
ZERK/GREASE
BEARING/ROLLER
SPACER
1
1
1
2
1
650733
121578
650486
113472
CS 5/16X2 1/2 (NILN)
CS 5/16X3/4 (NILN)
NUT/SPRING
1
1
2
2
PRINTED IN U.S.A.
1
1
1
AR
2
40
907286/AP0199
SL6625 - LIFT/TILT CONTROLS (HAND/FOOT)
9
16
15
2
13
9
14
10
8
6
12
6
6
7
1
2
6
3
2
11
5
2
3
4
2
1
3
907286/AP0199
41
PRINTED IN U.S.A.
SL6625 - LIFT/TILT CONTROLS (HAND/FOOT)
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Part
No.
Description
128892a
650545
078990b
650545
128316
BRACKET/BEARING
CS 5/16 X 1-1/4 (P,NILN)
BRACKET/BEARING
CS 5/16 X 1-1/4 (P,NILN)
BUSHING/PIVOT
2
4
2
4
5
056937
123648
075288
123650
075288
WASHER
PEDAL/LIFT
PIN/ROLL
PEDAL/TILT
PIN/ROLL
3
1
1
1
1
123383
650491
127506
653039
074868
JOINT/BALL
CS 3/8 X 1-1/4 (NILN)
TUBE/CONTROL
3/8 NF JAM NUT
SPACER
4
4
1
2
1
068919
650551
123654
127508
075228
PIN
PIN/COTTER
LEVER/SPOOL VALVE
LEVER ASSEMBLY
PIN/ROLL
3
3
1
1
1
123656
653039
123652
127485
068034
TUBE/CONTROL
3/8 NF JAM NUT
BUSHING
LEVER/VALVE
1/2 NILN (2P)
1
2
1
1
1
079039
650491
127479
653039
JOINT/BALL
CS 3/8 X 1-1/4 (NILN)
ROD/TAKE UP
3/8 NF JAM NUT
1
1
1
2
Quantity
b) Before SN8004.
PRINTED IN U.S.A.
42
907286/AP0199
SL6625 - HAND BRAKE
4
2
3
1
6
5
7
6
5
8
11
7
3
10
12
4
9
3
907286/AP0199
43
PRINTED IN U.S.A.
SL6625 - HAND BRAKE
Ref.
No.
1
2
3
4
5
6
7
8
9
10
11
12
Part
No.
Description
Quantity
6625SX
6625DX
079059
650493
072186a
072309
072425
MOUNT/ASSEMBLY RIGHT
CS 3/8 X 2-3/4 (L)
BRAKE/CALIPER RIGHT
CABLE/BRAKE
PIN/CLEVIS
1
2
1
2
2
1
2
1
2
2
655001
078982
650835
078996
081434
PIN/COTTER 1/16 X 3/4
DISC/BRAKE
CS 1/4 X 1 (L)
HUB/BRAKE
SHCS 3/8 X 1
2
2
6
2
2
2
2
6
2
2
079158
072185b
650692
072187a
079056
PIN/DRIVE
LEVER/BRAKE
CS 5/16 X 1-3/4 (NILN,P)
BRAKE/CALIPER LEFT
MOUNT/ASSEMBLY LEFT BRAKE
4
1
2
1
1
4
1
2
1
1
650493
092928
650486
092927
CS 3/8 X 2-3/4 (L)
CLAMP/BRAKE HANDLE
CS 5/16 X 3/4 (NILN)
EXTENSION/BRAKE HANDLE
2
1
1
1
2
1
1
1
a) For replacement lining, order Lining Kit 073693 which includes (2) Pads, (1) Backing Plate & mounting details.
b) Non-serviceable; replace as a complete assembly.
PRINTED IN U.S.A.
44
907286/AP0199
SL6625 - ROPS, SEAT & ENGINE COVER
1
2
2
1
24
23
24
5
4
6
17
18
19
16
11
13
12
15
11
10
7
10
9
8
21
22
907286/AP0199
45
PRINTED IN U.S.A.
SL6625 - ROPS, SEAT & ENGINE COVER
Ref.
No.
Part
No.
Description
072839
072838
072837
129636
079176
WEATHERSTRIP/WINDOW TOP & BOTTOM
WEATHERSTRIP/WINDOW SIDE
WINDOW/CAB REAR
COVER/ENGINE ASSEMBLY
GUARD/OVERHEAD
2
2
1
1
1
650867
072490
079275
651307
078580
HHCS 5/8 X 5 (NILN)
ISOLATOR
GUARD/CHANNEL ASSEMBLY
PHIL-PAN 1/4 X 1/2
POUCH/MANUAL
2
2
2
6
1
12
078581
121412
057557
650644
064543
RIVET/BLIND
BELT/SEAT
WASHER
HHCS 1/2 X 3 (NILN)
ISOLATOR/ROPS FRONT MOUNTING
4
1
6
2
2
13
14
15
16
17
R13247
074090
073103
079266
079192
SPRING/COMPRESSION
PIN/ROLL 3/16 X 1-1/2
PIN/STOP (3) 1/2P
SPRING/TORSION RIGHT
TUBE/PIVOT ASSEMBLY RIGHT
1
1
1
1
1
650490
074119
650490
074021
H6053
CS 3/8 X 1 (NILN)
TUBE/PIVOT ASSEMBLY LEFT
CS 3/8 X 1 (NILN)
SPRING/TORSION LEFT
SPACER
2
1
2
1
2
650487
130085a
070648
131691
122484
CS 5/16 X 1 (NILN, P)
SEAT/ASSEMBLY (INCLUDES ITEM 22)
5/16 FLANGE NUT
SET/SLIDE SEAT
SPRING/GAS
2
1
4
1
2
122485
071701
BALL/STUD
5/16 LN
4
4
1
2
3
4
5
6
7
8
9
10
11
18
19
20
21
22
23
24
Quantity
a) For Suspension Seat Assembly, order 091679
PRINTED IN U.S.A.
46
907286/AP0199
SL6625 - RESTRAINT BAR
14
10
5
12
10
9
11
9
10
15
3
13
9
9
6
11
9
7
8
4
10
2
1
907286/AP0199
47
PRINTED IN U.S.A.
SL6625 - RESTRAINT BAR
Ref.
No.
Part
No.
Description
1
2
3
4
5
078736
078734
128979
128984
078730
BAR/RESTRAINT
COVER/PIVOT
BRACKET/PIVOT RIGHT
BRACKET/PIVOT LEFT
SHAFT/PIVOT
1
2
2
2
2
6
7
8
121610
078942
078723
650551
128316
BEARING/PIVOT UPPER
SPRING/COMPRESSION
ACTUATOR/SPRING ASSEMBLY
PIN/COTTER
BUSHING/PIVOT
2
2
2
2
12
10
11
12
13
14
056937
067950
128943
128920
079265
WASHER
RING/EXTERNAL RETAINING
SPACER/LIMIT SWITCH
SWITCH/RESTRAINT BAR
SPACER
AR
4
1
1
4
15
650495
128872
CS 1/2 X 1-1/4 (P, L)
WIRE ASSEMBLY/LIMIT SWITCH
9
PRINTED IN U.S.A.
Quantity
4
1
48
907286/AP0199
SL6625 - SOUND DEADENING
6
5
1
7
2
4
8
3
907286/AP0199
49
PRINTED IN U.S.A.
SL6625 - SOUND DEADENING
Ref.
No.
Part
No.
Description
1
2
3
4
5
079390a
079389a
079623a
079622a
079625a
PAD/FOAM ROPS RIGHT REAR
PAD/FOAM ROPS LEFT REAR
FOAM/ROPS SIDE
FOAM/SEAT BACK ENGINE
FOAM/ROPS DECK
1
1
2
1
1
6
7
8
130088
130089
130114
FOAM/CEILING
FOAM/SEAT BACK
FOAM/ROPS BOTTOM
1
1
1
Quantity
a) Before SN8488.
PRINTED IN U.S.A.
50
907286/AP0199
SL6625 - INSTRUMENT PANEL, WIRING & COMPONENTS
1
3
2
5
6
30
27
8
7
4
14
4
9
15
12
11
10
15
16
21
17
16
18
19
20
22
29
24
26
Before SN8801
907286/AP0199
25
51
28
PRINTED IN U.S.A.
SL6625 - INSTRUMENT PANEL, WIRING & COMPONENTS
Ref.
No.
Part
No.
Description
1
2
3
4
5
075147
079258
079259
073696
076108
RETAINER/KEY
HOLDER/30 AMP FUSE
FUSE/30 AMP
BULB/12 VOLT
INDICATOR/FASTEN BELT
1
1
1
3
1
6
7
8
9
10
072345
072346
075104
069745
071149
INDICATOR/BATTERY LIGHT
INDICATOR/ENGINE OIL LIGHT
SWITCH/PUSH BUTTON
HOLDER/20 AMP FUSE
FUSE/20 AMP
1
1
1
1
1
11
12
13
072336
072337
079257
651308
651315
GAUGE/WATER TEMPERATURE
GAUGE/FUEL
PANEL/INSTRUMENT
RHMS 1/4 X 3/4
HHCS 5/16 X 3-1/2
1
1
1
3
4
14
15
16
17
089069a
067750
076058
650548
072340
SWITCH/IGNITION
NUT/SPEED 1/4
RELAY
RHMS #10-24 X 1/2 (N, L)
HOURMETER
1
3
2
2
1
18
19
20
21
650394
079196
079262
079261
063064
RHMS # 6-32 X 1/2 (N, L)
BUZZER
HARNESS/BUZZER
HARNESS/INSTRUMENT GROUND
CLIP 1/2
2
1
1
1
2
127476
650531
058805
650486
080868c
HARNESS/INSTRUMENT
TFS 1/4 X 1/2
CLAMP
CS 5/16 X 3/4 (N, L)
SWITCH/SEAT
1
1
3
2
1
28
130354b
114599b
128256
651343
072998
SEAT/SWITCH
COVER/MALE CONNECTOR
RETAINER/SWITCH
RHMS #10 X 1/2
COVER/HARNESS
1
1
1
2
1
29
30
650945
076681c
129928
THMS 1/4 X 3/4
TERMINAL (REPAIR)
LENS/GLOW PLUG INDICATOR
2
2
1
22
23
24
25
26
27
Quantity
a) For replacement Key Set (2 Keys on a ring), order 089070
b) SN8801 and later.
c) Before SN8801.
PRINTED IN U.S.A.
52
907286/AP0199
SL6625 - STANDARD LIGHTS, WIRING & COMPONENTS
8
7
5
4
6
5
6
4
7
2
1
3
907286/AP0199
53
PRINTED IN U.S.A.
SL6625 - STANDARD LIGHTS, WIRING & COMPONENTS
Ref.
No.
Part
No.
Description
1
2
3
4
5
073039
073036
073040
073687
077717
HARNESS/LIGHT
SWITCH/LIGHT
LIGHT/ASSEMBLY
GROMMET
TERMINAL/RING
1
1
2
2
3
6
122847
650687
070648
122011a
073686
BRACKET/LIGHT
CB 5/16 X 3/4
5/16 FLANGE NUT
LIGHT/WORK
GROMMET
2
2
2
1
1
7
8
Quantity
a) For replacement Bulb, order 122488; for replacement Lens, order 122489
PRINTED IN U.S.A.
54
907286/AP0199
SL6625 - BATTERY & ENGINE ELECTRICAL WIRING
12
17
1
3
20
11
7
16
15
13
14
Dual Pump Control
19
9
10
4
18
5
8
6
2
907286/AP0199
55
PRINTED IN U.S.A.
SL6625 - BATTERY & ENGINE ELECTRICAL WIRING
Ref
No.
Part
No.
Description
124018d
129731c
656048
656110
656047
HARNESS/ENGINE
HARNESS/ENGINE
NUT/M8
PLAIN WASHER/M8
NUT/M6
1
1
1
1
1
1
1
1
1
1
656114
650387
REFa
127406
064260
PLAIN WASHER/M6
RHMS #10-32 X 1/2 (P,L)
BATTERY/12 VOLT, GROUP 31, 950 COLD CRANKING AMPS
CLIP - COATED
5/16 NILN (P)
1
1
1
1
1
1
1
1
1
1
075028
650490
054985
077685
064260
CABLE/BATTERY NEGATIVE
CS 3/8 X 1 (N,L,P)
CABLE/ENGINE GROUND
ROD/BATTERY HOLD DOWN
5/16 NILN (P)
1
1
1
2
1
1
1
1
2
1
058615
122447e
078998f
081433
128501
CLAMP/HARNESS TO ENGINE
HOLD DOWN/BATTERY
HOLD DOWN/BATTERY
COVER/TERMINAL
CABLE/BATTERY
1
1
1
1
1
1
1
1
1
1
124062
650448
124063
650448
128373b
MODULE/QGS
CS 1/4 X 3/4 (NILN)
RELAY/QGS
CS 1/4 X 3/4 (NILN)
BRACKET/DUAL PUMP SWITCH
1
2
1
1
-
1
2
1
1
1
055924
129739c
127979d
129610
130208
SWITCH/TOGGLE DUAL PUMP
HARNESS/SOLENOIDS
HARNESS/SWITCH
SEAL/SWITCH
TIE-CABLE (USE WITH ITEM 12)
2
1
1
1
1
2
19
129738c
650387
650549
650648
076058c
HARNESS - START SOLENOID
RHMS - #10-32
LOCK WASHER - #10
HEX NUT- #10-32
RELAY
1
1
1
1
1
1
1
1
1
1
20
055648
TIE-CABLE (USE WITH ITEM 1)
2
2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
Quantity
6625SX
6625DX
a) Purchase locally.
b) Also order one P/N 123598 Decal/Hydraulic Operation.
d) Before SN8401.
e) SN7911 and later.
f) Before SN7911.
PRINTED IN U.S.A.
56
907286/AP0199
SL6625 - HYDRAULIC COMPONENTS
LIFT CYLINDER
3
2
1
8
4
8
5
6
7
Ref.
No.
Part.
No.
Description
1
2
3
128868a
079240b
080313
080312
128533
LIFT CYLINDER
LIFT CYLINDER
NUT/LOCK 1-14 UNC
PISTON
TUBE/ASSEMBLY
1
1
1
4
5
128923
570005
080314
080310
080308
BUSHING/SPRING
FITTING/GREASE
WELDMENT/TUBE
STOP/TUBE
GLAND
2
1
1
1
1
6
7
8
080309
080311
080307
HEADCAP/GLAND
WELDMENT/ROD
SEAL KIT
1
1
1
Quantity
b) Before SN8004.
907286/AP0199
57
PRINTED IN U.S.A.
TILT CYLINDER
3
1
2
7
7
4
5
6
Ref.
No.
Part.
No.
Description
1
2
3
4
123444
080313
080312
080320
080308
TILT CYLINDER
NUT/LOCK 1-14 UNC
PISTON
WELDMENT/TUBE
GLAND
1
1
1
1
5
6
7
080309
123424
080307
HEADCAP/GLAND
WELDMENT/ROD
SEAL KIT
1
1
1
PRINTED IN U.S.A.
Quantity
58
907286/AP0199
GRAPPLE CYLINDER
2
1
4
5
5
6
3
Grapple Cylinder 127408
LaterModels
Grapple Cylinder 067910
Early Models
907286/AP0199
59
PRINTED IN U.S.A.
GRAPPLE CYLINDER 067910
EARLY MODELS
Ref.
No.
Part.
No.
Description
1
2
3
4
067910
074266
063968
068420
063970
GRAPPLE CYLINDER
NUT/SELF-LOCKING
BARREL
SHAFT/CYLINDER
PISTON
1
1
1
1
5
6
067911
063969
KIT/SEAL
GLAND/HEAD
1
1
Quantity
LATER MODELS
GRAPPLE CYLINDER 127408
Ref.
No.
Part.
No.
Description
1
2
3
4
127408
073788
129602
129061
121564
GRAPPLE CYLINDER
NUT/SELF-LOCKING
BARREL
SHAFT/CYLINDER
PISTON
1
1
1
1
5
6
121569
121817
KIT/SEAL
GLAND/HEAD
1
1
PRINTED IN U.S.A.
Quantity
60
907286/AP0199
PLANETARY GEARCASE
1
2
3
4
5
6
7
Ref.
No.
Part.
No.
Description
1
2
3
4
078961
080300
080297
080296
080299
PLANETARY GEARCASE
RING/GEAR
CARRIER/SECONDARY
CARRIER/PRIMARY
GEAR/SUN
1
1
1
1
5
6
7
080303
080298
057569
WASHER/THRUST
COVER
PLUG/DRAIN
1
1
1
907286/AP0199
Quantity
61
PRINTED IN U.S.A.
BOOST CONTROL
4
2
3
4
5
6
8
1
7
10
14
9
11
13
6
12
Ref.
No.
Part.
No.
Description
Quantity
6625DX
1
2
3
4
087215a
129948
129939
129947
129946
BOOST CONTROL
BRACKET
SCREW/SPECIAL
SPRING
SLEEVE
1
1
1
2
5
6
7
8
9
129940
653039
087218
129941
129942
WASHER/SPECIAL
3/8NF JAM NUT
BUSHING
SHAFT
WASHER/SPECIAL
1
4
1
1
1
10
11
12
13
14
129944
064260
121187b
129943
129945
PLUG
5/16 NILN
SEAL KIT
SHAFT
STUD
1
1
1
1
1
a) Body not service separately.
b) Seal Kit includes: two Quad Rings, three Wipers, two Seals and two O-Rings.
PRINTED IN U.S.A.
62
907286/AP0199
DRIVE MOTOR
3
2
1
6
8
5
7
9
10
2
11
13
2
907286/AP0199
63
4
12
PRINTED IN U.S.A.
DRIVE MOTOR
Ref.
No.
Part.
No.
Description
1
2
3
4
079034
080768
080770
080771
081236
DRIVE MOTOR
RING/RETAINING
KIT/SEAL
HOUSING
PIN
1
1
1
2
5
6
7
8
9
080766
081233
080774
080767
080773
BEARING/CUP & CONE
SHAFT/MOTOR
KIT/ROTATING GROUP
KIT (OF 9)/PISTON SHOES
BLOCK/VALVE
1
1
1
1
1
10
11
12
13
650528
080765
080772
081224
CS 3/8 X 2
BEARING/CUP & CONE
PLATE/WAFER
KIT/BEARING SPACER
2
1
1
1
PRINTED IN U.S.A.
Quantity
64
907286/AP0199
TANDEM PUMP
3
2
9
7
2
1
8
4
7
10
2
2
6
6
5
12
8
13
4
11
14
16
15
18
17
27
26
20
24
22
26
22
23
21
25
2
19
20
18
16
32
14
15
28
12
33
2
3
2
11
7
5
6
6
8
4
31
2
907286/AP0199
10
30
29
9
8
7
65
2
PRINTED IN U.S.A.
TANDEM PUMP
Ref.
No.
Part.
No.
Quantity
6625SX
6625DX
Description
1
2
3
4
127548
080768
081232
080757
081247
TANDEM PUMP
RING/RETAINING
KIT/SEAL
BOLT
BOLT
1
1
12
12
1
1
12
12
5
6
7
8
9
080761
081223
080759
080758
080762
COVER
KIT/YOKE SHIM
SPACER
BEARING/CUP & CONE
HOUSING
2
2
4
4
2
2
2
4
4
2
10
11
12
13
650453
080760
080766a
080764
081237
CS 1/2 X 1-1/2 (L,P)
COVER/PINTLE
BEARING/CUP & CONE
YOKE
SHAFT/INTERMEDIATE
2
2
2
2
1
2
2
2
2
1
14
15
16
17
18
080767
080769
081224
114108
080765b
KIT (OF 9)/PISTON SHOES
KIT/ROTATING GROUP
KIT/BEARING SPACER
PLATE/WAFER-RIGHT
BEARING/CUP & CONE
2
2
1
1
2
2
2
1
1
2
19
20
21
22
23
080756
080754
080753
081235
081228
COUPLING
PLUG
SPACER
PIN
PLUG
1
3
4
2
1
1
3
5
2
1
24
25
26
27
28
081226
081227
129765
080755
081234
SPRING
POPPET
KIT/RELIEF VALVE
BLOCK/VALVE
SHAFT
1
1
4
1
1
1
1
4
1
1
29
30
31
32
33
081231
081230
081229
114109
650835
COUPLING/GEAR PUMP
RING/RETAINING
ADAPTER/PUMP
PLATE/WAFER-LEFT
CS 1/4 X 1 (L)
1
1
1
1
1
1
1
1
1
1
a) For replacement, order (1) 082269 Cone & (1) 520033 Cup.
b) For replacement, order (1) 054750 Cone & (1)041884 Cup.
PRINTED IN U.S.A.
66
907286/AP0199
SINGLE GEAR PUMP
1
3
3
3
1
3
3
2
Ref.
No.
Part.
No.
Description
1
2
3
127546
132546
132547
129535
SINGLE GEAR PUMP
FLANGE KIT
ENDCOVER
SEAL KIT
907286/AP0199
Quantity
6625SX
1
1
1
67
PRINTED IN U.S.A.
DUAL GEAR PUMP
1
2
2
2
2
2
3
Ref.
No.
Part.
No.
Description
1
2
3
127547
087194
087188
083241
DUAL GEAR PUMP
COVER/REAR PORTS
SEAL KIT
BODY/ASSEMBLY
PRINTED IN U.S.A.
Quantity
6625DX
1
1
1
68
907286/AP0199
MAIN CONTROL VALVE
1
2
3
7
4
5
6
Ref.
No.
Part.
No.
Description
1
2
3
4
079107
080332
080331
088953a
080328a
CONTROL VALVE
VALVE/RELIEF
SECTION/INLET
SECTION/LIFT
SECTION/TILT
1
1
1
1
5
6
7
080333a
080330
127629
SECTION/AUXILIARY
SECTION/OUTLET
KIT/DETENT SERVICE
1
1
1
Quantity
a) For repair, order Seal Kit 080327.
907286/AP0199
69
PRINTED IN U.S.A.
DIFFERENTIAL RELIEF VALVE
1
Ref.
No.
1
Part.
No.
Description
114446a
114447
RELIEF VALVE
CARTRIDGE/VALVE
Quantity
1
a) Valve body not serviced separately.
PRINTED IN U.S.A.
70
907286/AP0199
SN8031 AND LATER
SELF-LEVELING VALVE 128844
8
10
9
7
3
6
10
4
2
1
10
10
12
11
10
5
10
6
9
7
10
8
Ref.
No.
Part.
No.
Description
1
2
3
4
128844
080808
080809
080810
080811
SELF-LEVELING VALVE
PIN
CAP/ADJUSTMENT
NUT
SCREW/SET
1
1
1
1
5
6
7
8
9
129004
080813
088471
088472
088473
PLUG/ASSEMBLY
PLUG/ASSEMBLY
SPRING
PLUG/ASSEMBLY
CHECK/LOAD
1
2
2
1
1
129066
089961
350-27299
KIT/SEAL
SPRING
RING/RETAINING
1
1
1
10
11
12
907286/AP0199
Quantity
71
PRINTED IN U.S.A.
SELF-LEVELING VALVE 087274
BEFORE SN8031
8
12
9
1
7
4
12
5
3
2
12
12
13
12
6
12
7
11
9
12
10
Ref.
No.
Part.
No.
Description
1
2
3
4
087274a
080807
080808
080809
080810
SELF-LEVELING VALVE
PLUNGER
PIN
CAP/ADJUSTMENT
NUT
1
1
1
1
5
6
7
8
9
080811
080812
080813
080814
088471
SCREW/SET
PLUG/ASSEMBLY
PLUG/ASSEMBLY
PLUG/ASSEMBLY
SPRING
1
1
2
1
2
10
11
12
13
088472
088473
087275
089961
PLUG/ASSEMBLY
CHECK/LOAD
KIT/SEAL
SPRING
1
1
1
1
Quantity
a) No longer serviced as an assembly. Replaced by 128844 Self-Level Valve.
PRINTED IN U.S.A.
72
907286/AP0199
SOLENOID VALVE
6
2
3
7
5
1
4
8
SOLENOID VALVE 129314
Ref.
No.
Part.
No.
Description
1
2
3
4
129314
REFa
122840
129326
121897
SOLENOID VALVE
BODY
CARTRIDGE
COIL
KIT/SEAL
SN8401 AND LATER
Quantity
1
1
1
1
a) Valve body not serviced separately
SOLENOID VALVE 122900
Ref.
No.
Part.
No.
Description
5
6
7
8
122900
REFa
122840
121896
121897
SOLENOID VALVE
BODY
CARTRIDGE
COIL
KIT/SEAL
BEFORE SN8401
Quantity
1
1
1
1
a) Valve body not serviced separately.
907286/AP0199
73
PRINTED IN U.S.A.
SL6625 - ATTACHMENTS
UTILITY AND LIGHT MATERIAL BUCKETS
2
1
Later Attachment Hooks
Early Attachment Hooks
Ref.
No.
1
2
Part.
No.
Description
805777ab
806997ac
807168ac
089589
091043
65” UTILITY BUCKET
72” UTILITY BUCKET
72” LIGHT MATERIAL BUCKET
65” CUTTING EDGE (WEL-DON REPLACEMENT)
72” CUTTING EDGE (WELD-ON REPLACEMENT)
1
1
073458
STRIP/NON-SKID
1
Quantity
a) For early Attachment Hook replacement, order Hook Kit 802907.
b) For later Attachment Hook replacement, order Hook Kit 129955.
c) For later Attachment Hook replacement, order Hook Kit 129956.
PRINTED IN U.S.A.
74
907286/AP0199
68 INCH DIRT AND CONSTRUCTION BUCKET
2
4
3
Optional Teeth
1
Ref.
No.
1
2
3
4
Part.
No.
Description
806994ab
091046
073458
055944
058388
68” DIRT & CONSTRUCTION BUCKET
68” CUTTING EDGE (WELD-ON REPLACEMENT)
STRIP/NON-SKID
TOOTH/WELD-ON SHANK & CAP
CAP/TOOTH POINT
Quantity
1
1
9
9
a) For early Attachement Hook replacement, order Hook Kit 804717.
907286/AP0199
75
PRINTED IN U.S.A.
UTILITY FORK
1
2
3
Ref.
No.
1
2
3
Part.
No.
Description
804065ab
073458
089220
123377
655026
UTILITY FORK
STRIP/NON-SKID
FORK/UTILITY
TINE/UTILITY FORK
Quantity
1
1
1
9
9
a) For early Attachment Hook replacement, order Hook Kit 804717.
PRINTED IN U.S.A.
76
907286/AP0199
LATER MODELS
68 INCH INDUSTRIAL BUCKET AND GRAPPLE
23
4
6
3
5
8
2
3
16
15
24
3
14
7
9
24
22
16
2
23
1
1
8
14
10
9
10
14
17
11
14
18
14
18
19
22
18
17
11
18
18
11
18
19
12
20
13
21
25
20
907286/AP0199
77
PRINTED IN U.S.A.
68 INCH INDUSTRIAL BUCKET AND GRAPPLE
Ref.
No.
LATER MODELS
Part.
No.
Description
2
3
806323
128239
650490
128238
079097
INDUSTRIAL GRAPPLE
COVER/FRONT
CS 3/8 X 1 (NILN)
COVER/TOP
CLAMP/TUBE
2
8
2
2
4
5
6
7
8
079098
088046
122864
122865
128075
PLATE/TWIN
FITTING/ADAPTER
COUPLER/MALE
COUPLER/FEMALE
TUBE
2
2
1
1
2
9
10
11
12
13
123950
127408a
096494
073458
123949
PIN/FORK
CYLINDER/HYDRAULIC
PIN/FORK
STRIP/NON-SKID
COVER/TUBES
2
2
4
1
1
14
15
16
650533
129660
062400
128351
128503
CS 3/8 X 1-1/2
WASHER
TEE/UNION
HOSE/ASSEMBLY
COVER/NYLON HOSE (NOT SHOWN)
2
1
2
2
1
17
18
19
20
21
570002
072530
083037
083068
096445
FITTING/GREASE
BUSHING/LOAD ARM
FORK/INDUSTRIAL GRAPPLE
CONVERTER/BUCKET
BUCKET/INDUSTRIAL 68 INCH
8
8
2
2
1
22
23
24
096495
128223
128423
055648
128228
PIN/CYLINDER
HOSE/36 INCH ASSEMBLY
COVER/NYLON HOSE (NOT SHOWN)
TIE/WIRE
HOSE/31 INCH ASSEMBLY
2
2
2
6
2
25
096448
EDGE/CUTTING 68 INCH
1
1
Quantity
a) For breakdwon, see the pages titled “Hydraulic Components.”
PRINTED IN U.S.A.
78
907286/AP0199
EARLY MODELS
65 & 68 INCH INDUSTRIAL BUCKET AND GRAPPLE
11
18
1
7
6
9
2
12
3
4
10
1
5
1
6
8
7
7
13
2
14
3
3
4
14
5
15
14
13
15
17
16
17
907286/AP0199
79
PRINTED IN U.S.A.
65 & 68 INCH INDUSTRIAL BUCKET AND GRAPPLE
Ref.
No.
EARLY MODELS
Part.
No.
Description
806324
083049
057992
129660
067910a
INDUSTRIAL GRAPPLE
HOSE 3/8 X 32 (INCLUDES SPIRAL METAL PROTECTORS)
ELBOW/MALE 90 DEGREE
WASHER
CYLINDER/HYDRAULIC
2
4
4
2
570002
083047c
650725
067849
650488
FITTING/GREASE
PIN/CYLINDER
CS 5/16 X 2-1/4 (NILN)
CLAMP/HOSE
CS 3/8 X 3/4 (N,L)
4
4
4
2
2
7
8
9
10
11
083048
062400
083555
062274
079254
TEE/UNION
CONNECTOR/FLARE
2
2
2
2
1
12
13
079253
083046
650725
072530
083037
PIN/FORK
CS 5/16 X 2-1/4 (NILN)
BUSHING
FORK/ASSEMBLY
1
2
2
8
1
570002
083262
096448
083068
650491
FITTING/GREASE
65 INCH CUTTING EDGE
68 INCH CUTTING EDGE
CONVERTER/BUCKET
CS 3/8 X 1-1/4 (NILN)
4
1
1
2
12
660050
123947b
123948b
650490
073458
BUSHING/HEX 3/4 X 1/2
COVER/TOP
COVER/FRONT
CS 3/8 X 1 (NILN)
STRIP/NON SKID
2
2
2
8
1
123949b
650533
123950b
COVER/TUBES
CS 3/8 X 1-1/2 (NILN)
PIN/FORK
1
2
2
1
2
3
4
5
6
14
15
16
17
18
19
20
21
22
23
Quantity
a) For breakdown, see the pages titled “Hydraulic Components.”
b) Later units only.
c) Early units used quantity of four, later units used quantity of two.
PRINTED IN U.S.A.
80
907286/AP0199
PALLET FORKS
1
2
3
4
5
6
Dyson
Yale
21.25 (Yale)
20.25 (Dyson)
907286/AP0199
81
PRINTED IN U.S.A.
PALLET FORKS
Ref.
No.
Part.
No.
Description
1
2
3
804444
804442
128876
128877
129271
42” PALLET FORK
48” PALLET FORK
BRACKET/ASSEMBLY RIGHT
BRACKET/ASSEMBLY LEFT
EXTENSION/ASSEMBLY BACKREST
1
1
1
650503
090008
650710
092334
650532
CS 1/2 X 2-1/2 (NILN)
BAR
CS 5/8 X 2-1/4 (NILN)
STRAP/ASSEMBLY
CS 5/8 X 1-1/2 (NILN)
4
1
4
1
4
087390a
083071a
094160b
079441b
FORK/ASSEMBLY 42”
FORK/ASSEMBLY 48”
DECAL/CAUTION-BACKREST
DECAL/CAPACITY
2
2
1
1
4
5
6
Quantity
a) For repair of Fork Lock Lever, order either Lever Kit 090002 (for Yale Fork) or Lever Kit 090003 (for Dyson Fork).
b) Not shown
PRINTED IN U.S.A.
82
907286/AP0199
UTILITY GRAPPLE
11
1
12
2
20
10
7
9
3
4
8
6
5
20
14
2
15
13
4
5
14
17
15
15
14
6
18
19
17
16
19
14
907286/AP0199
83
15
PRINTED IN U.S.A.
UTILITY GRAPPLE
Ref.
No.
Part.
No.
Description
802898
055648
088911
055021
650488
UTILITY GRAPPLE
TIE/WIRE
HOSE 3/8 X 43
CLAMP/HOSE
CS 3/8 X 3/4 (N,L)
2
2
3
2
580116
067910a
570002
089244
056486
UNION/SWIVEL ADAPTER
CYLINDER/HYDRAULIC
FITTING/GREASE
PIN
U-BOLT
4
2
4
2
1
8
9
10
11
058655
089299
079253
079254
5/16 N,L
TEE/STEEL HYDRAULIC PIPE
HOSE 3/8 X 62
2
2
2
1
1
12
061112
650488
089240b
650453
H8054
SPRING/EXTENSION
CS 3/8 X 3/4 (N,L,P)
MOUNT/CYLINDER RIGHT
CS 1/2 X 1-1/2 (N,L,P)
WASHER
1
1
1
5
4
655020
089236c
650453
059453
651003
PIN/COTTER 3/16 X 1-1/2 Z
MOUNT/CYLINDER LEFT
CS 1/2 X 1-1/2 (N,L,P)
CLAMP/TUBE
HHTCS 3/8 X 1-1/2
4
1
5
2
2
089230
570002
061612
088910
GRAPPLE/ASSEMBLY
FITTING/GREASE
PIN/CYLINDER
HOSE 3/8 X 33
1
2
2
2
1
2
3
4
5
6
7
13
14
15
16
17
18
19
20
Quantity
a) For breakdown, see the pages titled “Hydraulic Components.”
b) For replacement, use 123456 Grapple Mount Right.
c) For replacement, use 123451 Grapple Mount Left.
PRINTED IN U.S.A.
84
907286/AP0199
NUMERICAL INDEX
SL6625 - INDEX
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
041884
041885
045026
046022
047269
050270
050270
050270
054202
054202
054202
054626
054626
054783
054818
054818
054819
054819
054819
054819
054820
054842
054985
055005
055005
055005
055021
055030
055064
055064
055064
055648
055648
055648
055924
055924
055944
055981
056085
056087
056088
056088
056089
056089
056089
056104
056104
056429
056486
056937
056937
056937
056937
056937
056937
057067
057490
057557
057569
057569
057650
057992
058388
12
12
32
6
10
36
38
40
20
36
40
24
24
14
24
24
18
20
14
24
14
10
56
24
14
24
84
30
24
14
24
56
78
84
24
56
75
14
22
14
22
14
18
14
24
24
24
22
84
10
36
38
40
42
48
30
34
46
6
61
14
80
75
058615
058615
058655
058805
059453
060039
060505
060505
060505
060508
060508
060508
061112
061166
061612
062023
062274
062282
062282
062397
062400
062400
062889
063064
063718
063718
063719
063968
063969
063970
064238
064260
064260
064260
064373
064543
064644
064644
064840
064840
064840
064861
065054
065057
065057
065057
065102
065102
065163
065164
065756
066580
067460
067487
067750
067761
067761
067847
067847
067847
067847
067847
067849
30
56
84
52
84
26
36
38
40
36
38
40
84
10
84
26
80
10
34
18
78
80
14
52
36
40
38
60
60
60
34
56
56
62
12
46
24
24
20
36
40
8
8
36
38
40
24
24
34
20
26
22
18
6
52
14
18
6
20
30
34
40
80
067888
067910
067910
067910
067911
067950
068034
068034
068034
068034
068034
068034
068420
068919
068938
069745
070613
070648
070648
071149
071701
072185
072186
072187
072309
072336
072337
072340
072343
072345
072346
072384
072384
072425
072490
072530
072530
072580
072587
072587
072587
072587
072587
072601
072615
072615
072837
072838
072839
072998
073036
073039
073040
073103
073115
073411
073458
073458
073458
073458
073458
073678
073686
8
60
80
84
60
48
14
30
34
34
34
42
60
42
14
52
34
46
54
52
46
44
44
44
44
52
52
52
10
52
52
14
30
44
46
78
80
18
14
18
20
14
24
26
24
24
46
46
46
52
54
54
54
46
10
14
74
75
76
78
80
32
54
073687
073696
073776
073788
074020
074021
074090
074093
074093
074093
074119
074266
074282
074830
074860
074868
074868
075028
075042
075104
075147
075173
075174
075228
075235
075235
075235
075235
075237
075287
075288
075288
075288
075288
075288
075288
075288
075288
075288
075288
075288
075288
075308
075503
075503
075503
076002
076002
076002
076002
076058
076058
076108
076147
076681
077685
077717
078056
078580
078581
078595
078612
078629
54
52
8
60
14
46
46
36
38
40
46
60
14
14
8
40
42
56
34
52
52
22
22
42
22
14
18
20
10
38
20
36
36
36
38
38
38
38
38
40
42
42
6
14
14
24
36
38
38
40
52
56
52
24
52
56
54
10
46
46
6
12
26
907286/AP0199
14
13
9
18
32
1
1
1
28
22
10
1
13
13
2
6
7
14
14
30
28
30
5
3
11
36
3
9
4
24
37
20
23
1
5
14
3
2
3
29
5
27
36
20
43
6
11
11
7
25
6
6
3
3
10
6
10
11
1
7
33
2
4
15
7
8
23
17
15
9
11
15
12
12
14
12
3
19
18
10
20
1
30
15
8
7
21
4
16
4
2
6
4
13
3
6
11
6
12
7
39
28
22
10
5
24
5
5
4
8
49
5
20
16
10
20
17
15
3
8
15
17
3
17
11
6
85
4
4
5
5
11
22
30
10
15
18
14
3
9
8
9
3
21
6
10
24
8
2
9
3
11
12
17
11
6
7
17
5
4
6
18
14
26
32
35
3
6
20
20
9
48
3
2
1
28
2
1
3
15
5
14
2
2
1
12
21
8
8
4
4
16
1
10
19
14
2
2
2
18
1
15
9
26
12
8
4
6
8
1
8
12
11
14
24
15
13
17
24
31
7
14
20
7
14
16
23
24
13
4
5
23
20
7
52
12
12
14
14
16
19
5
15
29
6
5
6
8
9
26
21
29
PRINTED IN U.S.A.
SL6625 - INDEX
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
078723
078730
078734
078736
078831
078912
078914
078919
078921
078921
078922
078931
078936
078942
078943
078944
078945
078946
078947
078948
078949
078952
078953
078955
078958
078959
078961
078961
078962
078981
078981
078982
078984
078984
078990
078990
078990
078996
078998
079010
079022
079022
079029
079029
079034
079034
079039
079039
079039
079039
079039
079042
079042
079042
079056
079059
079068
079068
079097
079097
079098
079098
079098
48
48
48
48
14
28
28
26
14
30
30
28
28
48
12
12
12
12
12
12
12
12
12
12
12
12
12
61
12
8
18
44
14
24
36
38
42
44
56
30
8
18
24
24
14
64
20
32
36
40
42
36
38
38
44
44
20
40
20
78
20
78
24
079100
079102
079102
079103
079103
079105
079105
079106
079106
079107
079107
079107
079108
079108
079109
079109
079111
079112
079114
079115
079116
079117
079119
079120
079121
079122
079131
079142
079147
079148
079152
079158
079167
079170
079171
079175
079176
079192
079196
079204
079205
079210
079212
079214
079216
079216
079240
079244
079253
079253
079254
079254
079257
079258
079259
079261
079262
079265
079266
079275
079279
079280
079282
14
14
24
14
24
14
24
14
24
69
14
24
22
18
14
24
18
18
20
22
20
20
18
18
18
18
8
8
8
8
12
44
6
10
10
18
46
46
52
8
8
34
34
34
36
38
57
20
80
84
80
84
52
52
52
52
52
48
46
46
8
18
18
079282
079283
079284
079288
079289
079289
079289
079306
079310
079335
079336
079339
079341
079368
079369
079389
079390
079416
079417
079417
079417
079417
079418
079418
079418
079418
079420
079420
079420
079423
079441
079482
079483
079614
079622
079623
079625
079757
080072
080296
080297
080298
080299
080300
080303
080304
080307
080307
080308
080308
080309
080309
080310
080311
080312
080312
080313
080313
080314
080320
080328
080330
080331
20
18
18
14
14
14
24
10
10
10
10
10
34
6
6
50
50
10
22
20
24
24
22
20
24
24
14
14
24
18
82
10
10
20
50
50
50
26
6
61
61
61
61
61
61
26
57
58
57
58
57
58
57
57
57
58
57
58
57
58
69
69
69
080332
080333
080534
080753
080754
080755
080756
080757
080758
080759
080760
080761
080762
080764
080765
080765
080766
080766
080767
080767
080768
080768
080769
080770
080771
080772
080773
080774
080807
080808
080808
080809
080809
080810
080810
080811
080811
080812
080813
080813
080814
080868
081223
081224
081224
081226
081227
081228
081229
081230
081231
081232
081233
081234
081235
081236
081237
081247
081433
081434
082800
083037
083037
69
69
10
66
66
66
66
66
66
66
66
66
66
66
64
66
64
66
64
66
64
66
66
64
64
64
64
64
72
71
72
71
72
71
72
71
72
72
71
72
72
52
66
64
66
66
66
66
66
66
66
66
64
66
66
64
66
66
56
44
20
78
80
PRINTED IN U.S.A.
8
5
2
1
16
2
11
21
31
22
23
16
8
7
7
8
3
4
9
20
18
16
12
15
11
10
1
2
2
12
5
1
25
15
17
1
6
8
18
14
29
10
26
12
27
7
24
11
15
18
13
20
10
1
26
7
6
3
7
4
8
25
19
57
16
33
4
22
3
21
13
56
7
9
12
28
23
5
15
2
11
12
38
21
19
27
13
11
17
12
25
7
20
14
13
22
5
17
18
3
6
4
18
7
8
9
9
12
10
11
11
13
2
3
20
19
14
16
7
9
11
1
86
10
14
18
26
13
23
53
31
29
8
9
6
11
21
22
2
1
15
17
1
11
10
16
4
12
9
30
21
38
37
6
2
1
21
4
3
5
3
24
3
2
6
4
1
5
5
8
7
5
4
6
5
4
7
2
2
1
1
3
3
4
6
2
1
5
4
21
20
27
19
3
8
7
10
5
9
12
11
18
5
11
8
14
1
1
15
2
3
12
9
7
1
1
2
2
3
3
4
4
5
6
6
7
8
24
6
13
16
24
25
23
31
30
29
2
6
28
22
4
13
4
9
6
16
19
15
NUMERICAL INDEX
Part
No.
907286/AP0199
NUMERICAL INDEX
SL6625 - INDEX
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
083046
083047
083048
083049
083068
083068
083071
083241
083262
083555
087014
087015
087024
087026
087027
087028
087030
087188
087194
087215
087215
087218
087274
087275
087390
087837
087837
087843
087843
087849
087851
087852
087854
087859
087860
087969
087972
087974
087975
087982
088035
088046
088046
088046
088120
088139
088140
088141
088199
088239
088239
088242
088249
088254
088267
088283
088283
088283
088470
088471
088471
088472
088472
80
80
80
80
78
80
82
68
80
80
22
22
22
22
22
22
14
68
68
14
62
62
72
72
82
24
24
24
24
28
26
10
8
28
28
32
32
32
32
28
10
24
78
24
14
10
10
10
34
36
38
36
40
20
14
24
14
24
12
71
72
71
72
088473
088473
088910
088911
088912
088912
088937
088946
088946
088953
089042
089069
089079
089091
089091
089092
089092
089095
089220
089230
089236
089240
089244
089299
089589
089961
089961
090008
091017
091043
091046
091059
091060
091869
092334
092576
092577
092927
092928
094160
095955
096236
096445
096448
096448
096494
096495
113472
113472
114108
114109
114212
114336
114446
114446
114446
114447
114599
114665
114715
114715
114883
115039
71
72
84
84
14
30
18
36
40
69
10
52
8
36
38
36
38
14
76
84
84
84
84
84
74
71
72
82
14
74
75
14
14
28
82
8
8
44
44
82
26
6
78
78
80
78
78
38
40
66
66
26
26
70
14
24
70
52
10
14
24
8
20
121002
121008
121050
121187
121412
121491
121564
121569
121578
121578
121578
121610
121684
121707
121773
121817
121896
121897
121897
122011
122083
122095
122095
122447
122484
122484
122485
122649
122756
122756
122840
122840
122847
122864
122864
122864
122864
122864
122865
122865
122865
122865
122865
122900
122900
122976
122978
123280
123280
123280
123377
123383
123420
123424
123444
123444
123509
123596
123601
123601
123637
123648
123650
20
10
14
62
46
26
60
60
36
38
40
48
14
8
14
60
73
73
73
54
14
36
38
56
38
46
46
18
24
24
73
73
54
22
20
24
78
24
22
20
24
78
24
18
73
12
12
36
38
40
76
42
36
58
18
58
26
26
36
38
38
42
42
123651
123652
123654
123656
123661
123667
123668
123668
123672
123672
123719
123722
123722
123725
123826
123827
123828
123829
123832
123859
123860
123865
123867
123886
123898
123905
123905
123922
123946
123947
123948
123949
123949
123950
123950
123964
123986
123987
124015
124018
124062
124063
124068
124069
124078
124080
124090
127200
127220
127320
127342
127344
127345
127357
127360
127360
127360
127389
127392
127396
127406
127408
127408
34
42
42
42
10
38
20
38
20
38
20
36
38
18
8
26
26
26
26
26
26
26
26
28
26
26
32
28
30
80
80
78
80
78
80
6
30
30
30
56
56
56
26
26
34
34
30
14
34
34
6
20
20
20
20
36
38
26
26
28
56
60
78
907286/AP0199
13
5
7
1
20
17
6
3
16
9
13
1
9
6
4
19
17
2
1
5
7
12
6
13
47
14
44
13
17
12
25
5
4
1
4
5
6
10
22
15
5
46
21
19
21
18
14
14
16
21
13
25
2
16
8
23
6
7
9
8
10
9
11
20
2
15
3
13
1
1
3
10
14
5
20
23
19
22
1
2
18
16
13
6
9
1
11
13
4
19
1
1
6
9
9
5
7
10
12
11
6
36
12
21
25
16
11
22
26
18
17
32
30
31
5
19
1
26
27
18
51
21
22
87
21
7
10
12
10
43
4
5
3
3
17
6
4
20
11
6
7
4
8
7
23
23
27
8
1
23
24
33
17
45
2
6
6
18
2
18
6
7
15
5
19
7
5
24
24
24
10
10
5
3
6
26
6
28
32
26
25
28
25
4
5
15
13
10
12
15
14
31
7
29
8
30
11
15
31
6
23
24
22
1
14
13
12
11
18
27
28
12
24
11
19
20
13
22
9
23
13
4
8
10
1
11
12
9
10
16
2
29
26
17
2
25
19
17
24
23
13
21
2
25
21
3
10
PRINTED IN U.S.A.
SL6625 - INDEX
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
127428
127445
127452
127465
127468
127473
127476
127479
127480
127480
127481
127482
127482
127482
127485
127486
127488
127488
127488
127491
127492
127495
127496
127497
127502
127505
127505
127506
127508
127509
127510
127511
127512
127525
127533
127546
127546
127547
127547
127548
127548
127556
127557
127558
127560
127567
127570
127571
127572
127573
127620
127629
127640
127644
127652
127659
127716
127722
127725
127725
127750
127779
127840
28
28
26
32
24
28
52
42
36
38
28
14
14
24
42
6
20
34
40
30
30
30
30
30
40
26
30
42
42
6
6
18
10
30
8
67
14
68
24
14
66
30
12
12
12
12
6
6
6
40
18
69
26
26
30
10
34
6
14
30
26
24
34
127948
127948
127950
127950
127953
127953
127966
127966
127971
127972
127979
127987
128031
128031
128048
128075
128091
128113
128179
128182
128190
128223
128224
128224
128228
128230
128231
128238
128239
128244
128244
128247
128247
128250
128250
128256
128261
128279
128300
128301
128305
128309
128316
128316
128316
128316
128317
128317
128318
128319
128320
128330
128330
128333
128333
128334
128334
128335
128351
128363
128367
128368
128373
24
24
24
24
24
24
24
24
18
18
56
28
24
24
10
78
10
32
26
30
24
78
24
24
78
28
28
78
78
24
24
24
24
24
24
52
26
26
18
18
26
26
36
38
42
48
24
24
24
24
24
24
24
24
24
24
24
24
78
28
8
8
56
128423
128426
128501
128503
128507
128522
128533
128584
128591
128622
128632
128806
128815
128816
128844
128844
128868
128868
128872
128876
128877
128892
128892
128892
128909
128920
128923
128943
128979
128984
128988
128993
129004
129059
129061
129066
129120
129271
129314
129314
129326
129346
129375
129376
129418
129460
129535
129602
129610
129616
129636
129660
129660
129731
129734
129735
129738
129739
129765
129769
129770
129928
129939
78
6
56
78
12
18
57
8
6
10
18
30
30
30
18
71
18
57
48
82
82
36
38
42
6
48
57
48
48
48
12
12
71
30
60
71
30
82
18
73
73
30
32
32
30
24
67
60
56
26
46
78
80
56
26
26
56
56
66
28
28
52
62
129940
129941
129942
129943
129944
129945
129946
129947
129948
130006
130021
130085
130088
130089
130114
130208
130336
130354
131083
131202
131560
131691
131848
132546
132547
133084
540020
570002
570002
570002
570002
570002
570002
570002
570002
570005
570005
570005
570005
570014
580116
650293
650354
650387
650387
650387
650394
650416
650448
650448
650448
650448
650449
650453
650453
650453
650484
650485
650485
650485
650485
650486
650486
62
62
62
62
62
62
62
62
62
6
6
46
50
50
50
56
32
52
12
32
28
46
36
67
67
28
18
8
12
18
78
80
80
84
84
8
18
18
57
8
84
10
12
34
56
56
52
10
6
28
56
56
30
66
84
84
32
30
30
30
30
10
10
PRINTED IN U.S.A.
20
19
7
11
40
17
22
16
17
19
1
18
22
54
14
11
18
8
8
14
13
2
25
24
6
8
16
7
11
16
8
6
33
1
1
25
35
22
7
27
29
19
28
17
15
9
9
17
7
39
34
12
23
12
14
31
22
42
41
9
20
50
21
27
22
24
23
17
34
25
15
12
24
12
26
8
24
2
6
30
34
23
25
2
24
22
23
2
1
26
31
27
29
28
32
27
35
4
3
4
33
41
16
18
2
9
29
42
55
4
1
30
14
31
18
32
16
3
16
15
18
19
13
88
23
10
10
16
26
2
3
22
4
4
32
26
21
20
10
16
15
1
2
15
17
1
19
13
3
12
3
4
22
23
5
19
3
10
28
3
24
3
17
10
3
27
40
3
2
16
43
4
14
3
1
37
38
18
15
26
6
3
30
2
5
8
9
13
10
14
4
3
1
2
3
21
6
7
8
17
1
25
24
4
14
22
7
1
2
25
31
23
21
16
17
4
15
5
18
1
16
28
3
8
4
5
16
5
1
18
17
31
23
23
11
12
23
9
13
16
4
19
20
21
29
13
32
NUMERICAL INDEX
Part
No.
907286/AP0199
NUMERICAL INDEX
SL6625 - INDEX
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
Part
No.
Page Ref.
No.
No.
650486
650486
650486
650486
650486
650486
650486
650486
650486
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650487
650488
650488
650488
650490
650490
650490
650490
650490
650490
650490
650491
650491
650491
650491
650492
650493
650493
650493
650495
650495
650495
650495
650495
650495
650503
650517
650517
650528
650528
650531
650532
650533
650533
650533
650533
650545
650545
650545
28
36
36
38
38
40
40
44
52
6
6
6
6
6
10
14
20
20
26
26
28
34
36
38
46
80
84
84
28
30
46
46
56
78
80
28
42
42
80
28
32
44
44
6
6
10
14
14
48
82
10
26
14
64
52
82
30
30
78
80
6
6
20
650545
650545
650545
650547
650548
650549
650551
650551
650551
650551
650551
650552
650552
650554
650572
650577
650579
650644
650648
650648
650648
650650
650687
650692
650694
650704
650706
650706
650710
650725
650725
650733
650733
650733
650733
650733
650733
650733
650733
650818
650818
650818
650835
650835
650835
650835
650835
650847
650850
650867
650898
650898
650916
650934
650934
650945
650964
651003
651017
651059
651062
651062
651085
36
38
42
18
52
56
20
34
40
42
48
36
38
12
12
32
34
46
20
34
56
8
54
44
26
10
10
10
82
80
80
8
8
18
18
18
20
36
40
14
32
36
10
26
32
44
66
12
8
46
36
38
6
6
6
52
12
84
8
32
36
38
12
651168
651168
651211
651307
651308
651312
651312
651315
651330
651343
652040
653010
653036
653036
653036
653039
653039
653039
653039
653039
653039
653039
653039
653119
655001
655001
655016
655018
655020
655026
656006
656006
656006
656010
656010
656047
656048
656083
656083
656083
656083
656083
656103
656103
656110
656114
656130
656181
656186
656188
660027
660046
660050
802898
804065
804442
804444
805777
806323
806324
806994
806997
807168
6
6
12
46
52
10
30
52
12
52
18
28
36
38
38
32
36
40
40
42
42
42
62
12
34
44
8
12
84
76
26
26
32
32
36
56
56
26
26
26
26
26
32
36
56
56
30
26
26
26
6
6
80
84
76
82
82
74
78
80
75
74
74
350-27299
420-32432
9H240
H6053
H8049
H8054
R13247
R13247
71
28
8
46
8
84
10
46
907286/AP0199
22
3
10
3
10
5
17
11
23
8
14
15
16
17
23
16
19
30
23
41
2
9
15
17
20
6
3
12
22
12
17
18
4
1
20
19
6
15
17
1
11
1
10
21
22
22
12
18
14
3
16
40
17
10
22
5
13
14
13
22
10
11
24
17
19
1
12
16
18
18
8
8
9
8
23
27
23
12
6
16
11
22
4
18
9
6
8
16
6
21
29
4
5
13
2
14
17
29
31
7
4
16
5
7
24
19
39
1
5
33
17
17
5
18
13
7
3
12
28
23
17
12
11
8
9
6
89
9
26
1
7
13
10
28
13
5
27
10
14
18
15
20
7
11
6
9
7
12
16
6
12
14
4
11
12
15
3
27
28
12
12
26
1
1
11
12
13
14
32
12
26
1
1
2
9
10
25
6
5
18
-
12
7
8
20
15
14
28
13
PRINTED IN U.S.A.
NOTES
PRINTED IN U.S.A.
90
907286/AP0199
Recommended Coupling & Adapter Installation Torque Specifications
For JIC 37° and 45°
(Machined or Flared)
For SAE “0" Ring Boss (Steel)
Size
Steel
Ft-Lbs
Dash
Fractional
(In.)
Minimum
Maximum
-3
-4
-5
-6
-8
3/16
1/4
5/16
3/8
1/2
8
14
18
24
50
10
16
20
26
60
-10
-12
-14
-16
-20
-24
5/8
3/4
7/8
1
1-1/4
1-1/2
72
125
160
200
210
270
80
135
180
220
280
360
907286/AP0199
Size
91
Ft-Lbs
Dash
Fractional
(In.)
Minimum
Maximum
-4
-5
-6
-8
-10
1/4
5/16
3/8
1/2
5/8
10
13
17
34
50
11
15
19
38
56
-12
-16
-20
-24
-32
3/4
1
1-1/4
1-1/2
2
70
94
124
156
219
78
104
138
173
243
PRINTED IN U.S.A.
Torque Specifications
Use these torque values when tightening GEHL hardware (excluding: Lock Nuts, and Self-tapping, Thread
Forming, and Sheet Metal Screws) unless otherwise specified.
Unified
National
Thread
Dry
Lubed
Dry
Lubed
Dry
Lubed
8-32
8-36
10-24
10-32
19*
20*
27*
31*
14*
15*
21*
23*
30*
31*
43*
49*
22*
23*
32*
36*
41*
43*
60*
68*
31*
32*
45*
51*
1/4-20
1/4-28
5/16-18
5/16-24
66*
76*
11
12
50*
56*
9
9
9
10
17
19
75*
86*
13
14
12
14
25
25
9
10
18
20
3/8-16
3/8-24
7/16-14
7/16-20
20
23
32
36
15
17
24
27
30
35
35
40
23
25
35
40
45
50
70
80
35
35
55
60
1/2-13
1/2-20
9/16-12
9/16-18
50
55
70
80
35
40
55
60
75
90
110
120
55
65
80
90
110
120
150
170
80
90
110
130
5/8-11
5/8-18
3/4-10
3/4-16
100
110
175
200
75
85
130
150
150
180
260
300
110
130
200
220
220
240
380
420
170
180
280
320
170
180
250
270
125
140
190
210
430
470
640
710
320
360
480
530
600
660
900
1000
460
500
680
740
7/8-9
7/8-14
1-8
1-12
Grade 2
Grade 5
Grade 8
Metric
Coarse
Thread
Dry
Lubed
Dry
Lubed
Dry
Lubed
M6-1
M8-1.25
M10-1.5
8
19
37.5
6
14
28
11
27
53
8
20
39
13.5
32.5
64
10
24
47
M12-1.75
M14-2
M16-2
65
103.5
158.5
48
76.5
117.5
91.5
145.5
223.5
67.5
108
165.5
111.5
176.5
271
82
131
200
Grade 8.8
Grade 10.9
Grade 12.9
*All Torque Values are in ft-lbs except those marked with an * which are in in-lbs.
For metric torque value (N·m) multiply ft-lbs value by 1.355 or the in-lbs value by 0.113.
®
Gehl Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A.
CALIFORNIA
Proposition 65 Warning
Diesel engine exhaust and some of its constituents are
known to the State of California to cause cancer, birth
defects and other reproductive harm.
907286/AP0199
© 1999 Gehl Company
All Rights Reserved.
PRINTED IN U.S.A.

Skid Loader - Hawkins Equipment

Transcription

Similar documents

personal watercraft - Greenhulk Personal Watercraft Performance Forums

THETFORD SPARES Porta Potti 145/165

Skid Loader - Hawkins Equipment