DL6 DL8 DL10 DL12 Dynalift Parts Manuals - German

Transcription

DL SERIES
Dynalift
®
Form No.
907878
Revision D
February
2008
DL6 / DL8 / DL10 / DL12*
*DL12 SN 50513 and before
Parts Manual
Telescopic Handlers
Introduction
DL Series Dynalift
NOTE: DL12 units (SN 505313 and before)
built after December 2007 are equipped with
TIER 3 and newer engines; refer to Parts
Manual #913272.
NOTE: This parts manual identifies standard
and optional features for this model. Depending
on the features of your machine, some of the
items identified in the parts lists may, or may not
be included with your machine.
The table of contents pages show the page locations
of various component groups on the machine.
Grease fittings and common attaching hardware, such
as cotter pins, set screws, woodruff keys, screws, nuts,
etc., are included in the parts list, indented below the
parts it is associated with, but NOT illustrated, except
where a particular routing or special fastening
arrangement MUST be maintained. The hardware listed is for mounting purposes and is NOT included
when the part is ordered for replacement.
Part numbers for standard bolts are listed indented
under the component being fastened, followed by
abbreviations for washers/nuts.
Standard attaching hardware torque values are provided on the inside back cover. Unless otherwise
specified, all cap screws are Grade 5, cadmium or
zinc plated; hexagon nuts for Grade 5 cap screws or
bolts are Grade 5.
When ordering service parts, specify the correct part
number, full description, quantity required, and the
unit model and serial number.
Model and serial numbers for this unit are stamped on
a plate located inside the operator’s station. The serial number is also stamped on the top front frame. The
following reference shows the breakdown of the serial number:
Capacity
Unit Number
Boom
Type
Engine
6H40JY0320172
Reach
Month
Year (X=06, Y=07, etc.)
“Right” and “left” are determined from a position
standing behind the unit and facing the direction of
travel.
GEHL Company reserves the right to make changes
or improvements in the design or construction of any
part of the unit without incurring the obligation to
install such changes on any unit previously delivered.
Gehl, Dynalift, Dynattach, Dynahandler and
Dynacarrier are registered trademarks of Gehl
Company.
DL Series Dynalift
Locator Reference
REAR
RIGHT
Boom
Engine
Transmission
Hydraulics
Transfer Case
Serial Number
Stamped Here
Attachment
Operator Station
Axle
Chassis
LEFT
FRONT
Outer Boom
First Intermediate Boom
Inner Boom
Four-Section High Boom Shown
Second Intermediate Boom
(Three-section booms do not have a first
or second intermediate section; they
have only one intermediate section.)
PRINTED IN U.S.A.
1
907878/DP0208
Table of Contents
Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Front Cover
Locator Reference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Table Of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
FILTERS
Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
DECALS
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Load Chart Reference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
OPERATOR’S STATION
Cab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Front Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
Windshield Wiper - Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Top Glass and Wiper (Early Style) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Top Glass and Wiper (Later Style) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32
Left Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34
Rear Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Upper Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
Lower Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44
Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48
Heater - A/C Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
A/C Condenser Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60
A/C Hoses, Compressor and Dryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62
Steering Column . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64
Console Tilt Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Brake Pedal Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68
Throttle Pedal Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70
Right Panel Plastic and Seat Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72
PERSONNEL WORK PLATFORM SYSTEM
Personnel Work Platform - Cab Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74
Personnel Work Platform - Boom Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76
Radio Remote - Transmitter and Receiver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78
CHASSIS
Rear Access Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80
Engine / Transmission Cover Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82
Battery Tray Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84
Hydraulic Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86
Fuel Tank Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88
Outriggers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
907878/DP0208
2
PRINTED IN U.S.A.
Table of Contents
Page
ENGINE
External Engine Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
Radiator Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96
Engine Air Cleaner Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100
Engine Muffler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .106
TRANSFER CASE
Transfer Case External Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .108
Transfer Case Assembly Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110
TRANSMISSION
External Transmission and Drive Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Converter Housing Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116
Case Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118
Torque Converter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119
Charging Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120
Pump Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .121
Forward Low/High Shaft and Gears Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122
Reverse/1st Shaft and Gears Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .126
2nd Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .130
Input Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132
Output Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133
Drive Plate Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134
Control Valve Mounting Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .135
Control Valve Assembly Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136
AXLES (26.25 and 26.28)
External Components Group (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .138
Front Axle Housing (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .140
Front Axle Swivel Housing and Steer Cylinder (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . .142
Front Axle Gear and Pinion Set (26.25 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .144
Front Axle Gear and Pinion Set (26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .145
Front Axle Differential (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .146
Front Axle Double Joint Shaft (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Front Axle Brakes (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .148
Front Axle Wheel Hub (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150
Front Axle Planetary Drive (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .151
Rear Axle Housing (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152
Rear Axle Swivel Housings and Steer Cylinder (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . .154
Rear Axle Gear and Pinion Set (26.25 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .156
Rear Axle Gear and Pinion Set (26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .157
Rear Axle Differential (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .158
Rear Axle Double Joint Shaft (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .159
Rear Axle Wheel Hub (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160
Rear Axle Planetary Drive (26.25 and 26.28 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .161
Axles continued on next page.
PRINTED IN U.S.A.
3
907878/DP0208
Table of Contents
Page
AXLES (26.48)
External Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162
Axle Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .164
Swivel Housing and Steer Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .166
Gear and Pinion Set (Front Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .168
Gear and Pinion Set (Rear Axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .169
Differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .170
Double U-Joint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .171
Wheel Hub and Final Reduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .172
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .173
BOOM
Low Boom
Three-Section Low Boom - Outer Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .174
Three-Section Low Boom - Outer Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .176
Three-Section Low Boom - Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . .178
Three-Section Low Boom - Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . .180
Three-Section Low Boom - Intermediate Boom - Chain Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . .182
Three-Section Low Boom - Intermediate Boom - Hose Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .184
Three-Section Low Boom - Inner Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .186
Three-Section Low Boom - Inner Boom - Hose Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .188
Four-Section Low Boom - Outer Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .190
Four-Section Low Boom - Outer Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .192
Four-Section Low Boom - First Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . .194
Four-Section Low Boom - First Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . .196
Four-Section Low Boom - Second Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . .198
Four-Section Low Boom - Second Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . .200
Four-Section Low Boom - Inner Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .202
Three and Four-Section Low Boom - Inner Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . .204
Manual Dynacarrier® Bracket (Low Boom) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .206
Dynattach® Bracket (Low Boom) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .208
High Boom
Three-Section High Boom - Outer Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .210
Three-Section High Boom - Outer Boom - Side Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .212
Three-Section High Boom - Outer Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .214
Three-Section High Boom - Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . .216
Three-Section High Boom - Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . .218
Three-Section High Boom - Intermediate Boom - Chain Group . . . . . . . . . . . . . . . . . . . . . . . . . . . .220
Three-Section High Boom - Intermediate Boom - Hose Tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .222
Three-Section High Boom - Inner Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .224
Four-Section High Boom - Outer Boom - Rear and Side Section . . . . . . . . . . . . . . . . . . . . . . . . . .226
Four-Section High Boom - Outer Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .228
Four-Section High Boom - First Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . .230
(Continued on next page.)
907878/DP0208
4
PRINTED IN U.S.A.
Table of Contents
Page
High Boom (continued).
Four-Section High Boom - First Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . .232
Four-Section High Boom - Second Intermediate Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . .234
Four-Section High Boom - Second Intermediate Boom - Front Section . . . . . . . . . . . . . . . . . . . . . .236
Four-Section High Boom - Inner Boom - Rear Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .238
Four-Section High Boom - Inner Boom - Front Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .240
Manual Dynacarrier® Bracket (High Boom) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .242
Dynattach® Bracket(High Boom) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .244
HYDRAULIC SYSTEMS
Hydraulic Pump and Accumulator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .246
Hydraulic Pump with Outrigger Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .248
SAHR and Accumulator Charge Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .250
SAHR with PWP Valve - Early Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .252
Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .254
Steer/Brake Lines Manifold (26.25 and 26.28 axles) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .256
Steer/Brake Lines Manifold (26.48 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .258
Park Brake Intensifier (26.48 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .260
Steer/Brake Lines on Axle (26.25 and 26.28 axles) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .262
Steer/Brake Lines on Axle (26.48 axle) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .264
Brake Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .266
Steer Motor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .267
Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .268
V40 Main Valve Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .270
Pilot Manifold - Tri-Function (4-Button) Joystick - Standard Hydraulics . . . . . . . . . . . . . . . . . . . . .274
Pilot Manifold - Tri-Function (4-Button) Joystick - Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . . . .276
Pilot Manifold - Tri-Function (4-Button) - Radio Remote Option . . . . . . . . . . . . . . . . . . . . . . . . . . .278
Pilot Manifold - Dual-Function (2-Button) Joystick - Standard Hydraulics . . . . . . . . . . . . . . . . . . . .280
Pilot Manifold - Dual-Function (2-Button) Joystick - Radio Remote Option . . . . . . . . . . . . . . . . . .282
Pilot Manifold - Dual-Function (2-Button) Joystick - Auxiliary Hydraulics . . . . . . . . . . . . . . . . . . .284
Pilot Manifold - Dual-Function (2-Button) Joystick - Radio Remote with Auxiliary Hydraulics . . .286
V20 Valve (Outriggers) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .288
Pilot Manifold - Outriggers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .290
Joystick Controller Group -Tri-Function (4-Button) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .292
Joystick Controller Group- Dual-Function (2-Button) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .294
Return Manifold and Filter Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .296
Frame Level Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .298
Frame Stabilizer Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .300
Lift Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .302
Slave Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .304
Continued on next page.
PRINTED IN U.S.A.
5
907878/DP0208
Table of Contents
Page
HYDRAULIC SYSTEMS (Continued)
Tilt Cylinder Group - Low Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .306
Tilt Cylinder Group - Low Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .308
Tilt Cylinder Group - High Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .310
Tilt Cylinder Group - High Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .312
Extend Cylinder Group - Low Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .314
Extend Cylinder Group - Low Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .316
Extend Cylinder Group - High Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .318
Extend Cylinder Group - High Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .320
Auxiliary Hydraulics - Low Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .322
Auxiliary Hydraulics - Low Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .324
Auxiliary Hydraulics - High Boom - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .326
Auxiliary Hydraulics - High Boom - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .328
Coolers Group - Hydraulic and Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .330
HYDRAULIC COMPONENTS
Flow Divider . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .334
Joystick Disengage Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .335
SAHR Valve (Late) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .336
SAHR Valve (Early) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .337
Steer Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .338
Level Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .339
V40 Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .340
Auxiliary Hydraulics V40 Work Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .344
Pilot Manifold - Dual-Function (2-Button) Joystick Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .346
Pilot Manifold - Tri-Function (4-Button) Joystick Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .347
Radio Remote Manifold (Option) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .348
V20 Outrigger Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .350
Outrigger Pilot Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .352
Joystick Controller - Tri-Function (4-Button) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .354
Joystick Controller - Dual-Function (2-Button) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .356
Stabilizer Cylinder Manifold Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .360
Frame Level Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .362
Frame Stabilizer Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .364
Lift Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .366
Slave Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .368
Tilt Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .370
Boom Extend Cylinder - Three-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .372
Boom Extend Cylinder - Four-Section Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .374
Outrigger Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .376
Dynacarrier® Lock Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .378
Swing Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .379
Rotate Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .380
Continued on next page.
907878/DP0208
6
PRINTED IN U.S.A.
Table of Contents
Page
HYDRAULIC COMPONENTS (Continued)
Fork-Shift Carriage Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .382
Grapple Cylinder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .383
Park Brake Caliper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .384
ATTACHMENTS
Personnel Work Platform . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .386
Forks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .390
Dynattach® Attachments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .392
Standard Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .392
Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .394
Swing Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .398
Log/Pipe Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .400
Fork-Shift Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .402
Bucket, 1.3-cubic yard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .403
Truss Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .404
Dynacarrier® Attachments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .406
Standard Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .406
Rotating Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .408
Log/Pipe Carriage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .412
Truss Boom, Booms with Winch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .414
Dual Top Clamp Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .418
NUMERICAL INDEX
Numerical Index List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .421
PRINTED IN U.S.A.
7
907878/DP0208
Filters
DL Series Dynalift
Filters
4
3
1
6
3-1/2”
5”
2
5
Fuel Filters
Oil Filters
Safety Air Filter
9
7
8
Transmission
Filter
Hydraulic
Filter
Primary Air
Filter
907878/DP0208
8
PRINTED IN U.S.A.
DL Series Dynalift
Filters
Filters
Ref.
No.
Part
No.
Description
Qty.
Req.
01af
02e
00g
102173
L99420
078849
-- ENGINE OIL FILTER -ENGINE OIL FILTER (John Deere). 1
ENGINE OIL FILTER (John Deere). 1
ENGINE OIL FILTER (Perkins 4.0L) 1
03b
04c
05d
00g
L98978
102174
103441
L88976
-- ENGINE FUEL FILTER -FUEL FILTER (John Deere) . . . . . . 1
FUEL FILTER (John Deere) . . . . . . 1
SEDIMENT BOWL (John Deere) . . 1
FUEL FILTER (Perkins 4.0L). . . . . . 1
06
07
L99967
L99453
-- ENGINE AIR FILTER -SAFETY AIR FILTER (inner) . . . . . . 1
PRIMARY AIR FILTER (outer) . . . . 1
08h
L99459
-- HYDRAULIC FILTER -HYDRAULIC FILTER. . . . . . . . . . . . 1
09
L99440
-- TRANSMISSION FILTER -TRANSMISSION FILTER . . . . . . . . 1
PRINTED IN U.S.A.
Ref.
No.
Part
No.
Description
Qty.
Req.
a Use dust seal PN 102742 as needed.
b Units equipped with manual accelerator pedal.
This filter measures 3-1/2” high; as shown in the
illustration.
c Units equipped with electronic accelerator pedal.
This filter measures 5” high; as shown in the illustration.
d Replace as needed.
9
e
DL6L SN 25615 and before
DL6H SN 20823 and before
f
DL6L SN 25616 and up
DL6H SN 20824 and up
g
Part not shown in illustration.
h
If needed, order PN L500352 o-ring set.
907878/DP0208
Decals
DL Series Dynalift
GENERAL INFORMATION
PAINT FINISH
Use this list to order paint for refinishing:
CAUTION
167788
167789
167758
167760
167754
167755
ALWAYS read and follow the safety precautions and information shown on decals. If any
decals are damaged or unreadable, or if the
unit is repainted, the decals must be
replaced. If repainting, BE SURE that all
decals that apply to your machine are affixed
in their proper locations.
Decal Kits
Decal locations information is provided to assist in
the proper selection and application of new decals, in
the event the original decals become damaged or the
machine is repainted.
For correct replacement of decals, compare the location photographs to your machine before starting to
refinish the unit. Check off each required decal using
the illustration reference number to find the part number, description and quantity in the list. Refer to the
appropriate illustration for replacement location.
If a part with a decal affixed is replaced, the decal
must also be replaced; affixed to the new part.
NOTE: Refer to the SAFETY chapter of the
Operator’s Manual for specific information provided on the various safety decals.
NEW DECAL APPLICATION
Before applying the new decals, surfaces must be free
from dirt, dust, grease and other foreign material. To
apply a solid-formed decal, remove the smaller portion of the decal backing paper and apply this part of
the exposed adhesive backing to the clean surface
while maintaining proper position and alignment.
Slowly peel off the other portion of the backing paper
while applying hand pressure to smooth out decal surface. To apply a pre-mask decal, first remove the
backing paper to expose the adhesive side of the
decal. Then, properly orient and position the decal
onto the clean mounting surface. After the decal is
907878/DP0208
Yellow; four quarts
Yellow; six 12 oz. Spray Cans)
Charcoal Gray, four quarts
Charcoal Gray; six (12 oz. Spray Cans)
Gun Metal Gray; four quarts
Gun Metal Gray; six (12 oz. Spray Can)
L500919
103426
L500920
103427
L500921
103428
L500922
103429
L500923
103430
L500924
103431
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
DL6H 40 w/ PWP
DL6H 40 w/o PWP
DL6L 40 w/ PWP
DL6L 40 w/o PWP
DL6H 42 w/ PWP
DL6H 42 w/o PWP
DL6L 42 w/ PWP
DL6L 42 w/o PWP
DL6H 44 w/ PWP
DL6H 44 w/o PWP
DL6L 44 w/ PWP
DL6L 44 w/o PWP
L500925
103432
L500926
103433
L500927
103434
L500928
103435
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
DL8H 42 w/ PWP
DL8H 42 w/o PWP
DL8L 42 w/ PWP
DL8L 42 w/o PWP
DL8H 44 w/ PWP
DL8H 44 w/o PWP
DL8L 44 w/ PWP
DL8L 44 w/o PWP
L500929
103436
L500930
103437
L500931
103438
L500932
103439
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Decal
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
Kit,
DL10H 44 w/ PWP
DL10H 44 w/o PWP
DL10L 44 w/ PWP
DL10L 44 w/o PWP
DL10H 55 w/ PWP
DL10H 55 w/o PWP
DL10L 55 w/ PWP
DL10L 55 w/o PWP
L500933
103440
Decal Kit, DL12H 40 w/ PWP
Decal Kit, DL12H 40 w/o PWP
NOTE: Decals may be purchased in kits or
individually.
10
PRINTED IN U.S.A.
DL Series Dynalift
Decal Locations
10
9
5
4
6
15
14
7
3
12
17
18
11
1
16
8
2
13
DECAL LOCATIONS - OPERATOR’S STATION
REF.
NO.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
DESCRIPTION
WARNING - SEAT BELT AND PARK BRAKE
IGNITION
DANGER - PERSONNEL INJURY (units w/o PWP)
WARNING - ROLLOVER HAZARD
WARNING - CARRY LOAD LOW
DANGER - HI-VOLT/MOVING PARTS
WARNING - TILT HAZARD/GENL. OPER.
JOYSTICK CONTROL
MADE IN USA
F-N-R SHIFTER
FUSES/RELAYS REFERENCE
MAINTENANCE CHART
OPERATOR MANUAL
WARNING - NO RIDERS
SHIFTER 1,2,3,4
WARNING - BACKUP ALARM
LOAD ZONE CHARTS
PWP LOADCHART USAGE (units w/o PWP)
DL6
DL8
DL10
101506
101507
L65928
L65930
093475
L70307
L70306
L70339
140516
L68295
101451
L70243
100359
L65932
L500439
L500445
See Note
103376
101506
101507
L65928
L65930
093475
L70307
L70306
L70339
140516
L68295
101451
L70243
100359
L65932
L500439
L500445
See Note
103376
101506
101507
L65928
L65930
093475
L70307
L70306
L70339
140516
L68295
101451
L70243
100359
L65932
L500439
L500445
See Note
103376
DL12
101506
101507
L65928
L65930
093475
L70307
L70306
L70339
140516
L68295
101451
L70243
100359
L65932
L500439
L500445
See Note
103376
Note: See Load Zone Charts section of this manual for individual load zone chart part numbers.
PRINTED IN U.S.A.
11
907878/DP0208
Decal Locations
DL Series Dynalift
DECAL LOCATIONS - TRUCK FRAME and BOOM
5
4
1
3
8
6
2
3
8
7
907878/DP0208
12
PRINTED IN U.S.A.
DL Series Dynalift
Decal Locations
DECAL LOCATIONS - TRUCK FRAME and BOOM
REF.
NO.
01
02
DESCRIPTION
GEHL,
GEHL,
GEHL,
GEHL,
6.38”
6.75”
8.00”
8.00”
(solid color decal)
(3-D style decal)
(solid color decal)
(3-D style decal)
DL6
DL8
DL10
DL12
101466
184069
101467
102025
101466
184069
101467
102025
101466
184069
101467
102025
101466
184069
101467
102025
03
DL6H
DL6L
DL8H
DL8L
DL10H
DL10L
DL12H
101469
101470
-----------
----101471
101472
-------
--------101473
101474
---
------------101475
04
HALF ZONE MARKER (5 ea. 40’ Booms)
HALF ZONE MARKER (6 ea. 42’, 44’, & 55’ Booms)
L62583
--L62583
--L62583
L62583
---
05
“1”
“2”
“3”
“4”
“5”
L67719
L67720
L67721
L67722
L67723
L67719
L67720
L67721
L67722
L67723
L67719
L67720
L67721
L67722
L67723
L67719
L67720
L67721
L67722
L67723
06
DYNALIFT,
DYNALIFT,
DYNALIFT,
DYNALIFT,
103357
L70438
103358
L70439
103357
L70438
103358
L70439
103357
L70438
103358
L70439
103357
L70438
103358
L70439
101476
101477
101478
---
--101477
101478
---
----101478
101479
L70440
-------
07
08
EXTENSION
EXTENSION
EXTENSION
EXTENSION
EXTENSION
MARK
MARK
MARK
MARK
MARK
(1
(1
(1
(1
(1
ea.)
ea.)
ea.)
ea.)
ea.)
3.25” (dark gray)
3” (light gray)
4.50”
4”
40
42
44
55
PRINTED IN U.S.A.
13
907878/DP0208
Decal Locations
DL Series Dynalift
DECAL LOCATIONS - FRAME and BOOM
1
1
1
1
8
7
4
2
3
9
11
5
10
17
12
13
1
1
6
15
16
17
907878/DP0208
14
PRINTED IN U.S.A.
DL Series Dynalift
Decal Locations
DECAL LOCATIONS - FRAME and BOOM
REF.
NO.
DESCRIPTION
DL6
DL8
DL10
DL12
01
02
03
04
WARNING - PINCH POINT
DANGER - JUMPSTART
WARNING - GAS CYLINDERS
DANGER - HANDS OUT
L65927
L65933
122745
L70305
L65927
L65933
122745
L70305
L65927
L65933
122745
L70305
L65927
L65933
122745
L70305
05
05
GEHL, 2.0” (solid color decal)
GEHL, 2.0” (3-D style decal)
101468
102026
101468
102026
101468
102026
101468
102026
06
06
GEHL, 5.25” (solid color decal)
GEHL, 5.00” (3-D style decal)
L70464
102027
L70464
102027
L70464
102027
L70464
102027
07
08
09
10
11
HYDRAULIC OIL
ACCUMULATOR DISCHARGE
DIESEL FUEL
ANTI-FREEZE
COOLANT UNDER PRESSURE
072794
L70238
072797
056859
072798
072794
L70238
072797
056859
072798
072794
L70238
072797
056859
072798
072794
L70238
072797
056859
072798
12
13
14
PERSONNEL LIFT(with PWP)
PERSONNEL LIFT SAFETY RULES (with PWP)
DANGER - PERSONLIFT(without PWP)
L71554
L71700
L65928
L71554
L71700
L65928
L71554
L71700
L65928
L71554
L71700
L65928
15
16
17
DYNATTACH UNLOCKED
DYNATTACH DIAGRAM
CARRY LOAD LOW
L66613
L65937
L65926
L66613
L65937
L65926
L66613
L65937
L65926
L66613
L65937
L65926
PRINTED IN U.S.A.
15
907878/DP0208
Decal Locations
DL Series Dynalift
DECAL LOCATIONS - PWP EQUIPPED UNITS
3
2
4
1
5
6
2
REF.
NO.
01
02
03
04
05
06
DESCRIPTION
PWP SWITCH INSTRUCTION
PERSONNEL LIFT
WORK PLATFORM RULES
PERSONNEL LIFT SAFETY RULES
PWP LOAD ZONE CHART
PWP SYSTEM
DL6
DL8
DL10
102969
L71554
L71555
L71700
See Note
103028
102969
L71554
L71555
L71700
See Note
103028
102969
L71554
L71555
L71700
See Note
103028
DL12
102969
L71554
L71555
L71700
See Note
103028
Note: See Load Zone Charts section of this manual for individual PWP load zone chart part numbers.
907878/DP0208
16
PRINTED IN U.S.A.
DL Series Dynalift
Load Chart Reference
DL - 6
DL6L / 42
DL6H / 40
Decal
Description
Decal
Description
L70488
L70974
L70535
L70550
L70555
L70532
L70997
L71064
L71711
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
L70780
L70982
L70782
L70783
L70784
L70785
L70994
L71063
L71744
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
DL6H / 44
DL6L / 40
Decal
Description
Decal
L70498
L70977
L70545
L70560
L70569
L70542
L70996
L71065
L71745
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
L70730
L70984
L70732
L70733
L70734
L70735
L70993
L71060
L71741
Description
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
DL6L / 44
DL6H / 42
Decal
Description
Decal
L70770
L70980
L70772
L70773
L70774
L70775
L70995
L71062
L71743
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
L70740
L70985
L70742
L70743
L70744
L70745
L70992
L71061
L71742
Description
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
For additional plastic load chart plates order PN L69402
PRINTED IN U.S.A.
17
907878/DP0208
DL Series Dynalift
DL - 8
DL8H / 42
Decal
L70489
L70975
L70536
L70551
L70556
L70533
L70991
L70721
L71739
DL8H / 44
Description
Decal
Description
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
L70750
L70981
L70752
L70753
L70754
L70755
L70989
L71057
L71737
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
DL8L / 44
DL8L / 42
Decal
L70499
L70978
L70546
L70561
L70570
L70543
L70990
L71059
L71740
Description
Decal
Description
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
L70760
L70983
L70762
L70763
L70764
L70765
L70988
L71058
L71738
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
907878/DP0208
18
PRINTED IN U.S.A.
DL Series Dynalift
DL - 10 and DL - 12
DL10L / 55
DL10H / 44
Decal
Description
L70490
103173
L70537
L70552
L70557
L70534
L70987
L70720
L71734
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
Outriggers Up
Decal
Description
L71108
103171
L71130
L71132
L71128
L71134
L71136
101108
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
WINCH
SWING CARRIAGE
PWP
DL10L / 44
Decal
DL10L / 55
Description
L70500
103174
L70547
L70562
L70571
L70544
L70986
L71056
L71735
Outriggers Down
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
Decal
Description
L71109
103172
L71131
L71133
L71129
L71135
L71137
101109
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
WINCH
SWING CARRIAGE
PWP
DL10H / 55
Outriggers Up
Decal
Description
L71091
103169
L71117
L71119
L71115
L71121
L71123
101106
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
WINCH
SWING CARRIAGE
PWP
DL10H / 55
DL12H / 40
Outriggers Down
Decal
Description
L71092
103170
L71118
L71120
L71116
L71122
L71124
101107
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
WINCH
SWING CARRIAGE
PWP
PRINTED IN U.S.A.
19
Decal
Description
L71093
103168
L71149
L71150
L71151
L71152
L71153
L71154
L71736
STANDARD CARRIAGE
ROTATE CARRIAGE
12 FT. TRUSS BOOM
15 FT. TRUSS BOOM
1.3 CU. YD BUCKET
2.5 CU. YD. BUCKET
WINCH
SWING CARRIAGE
PWP
907878/DP0208
Operator’s Station
DL Series Dynalift
Cab (Part 1 of 3)
24
Early Style Cab
20
21
22
23
1
3
2
19
4
5
7
6
8
18
9
10
17
16
2
3
15
5
Later Style Cab
(shown)
14
13
907878/DP0208
20
PRINTED IN U.S.A.
DL Series Dynalift
Cab (Part 1 of 3)
Ref.
No.
Part
No.
Description
01
Qty.
Req.
24abc
L500058
101713
L500068
OPEN CANOPY (cab weldment) . . 1
(note a, b and c) [canopy kit] (yellow)
(note d)
(note e) (Yellow Cab)
(note e) (Gray Cab)
7/8”-9X5” HEX GR 5 . . . . . . . . . . . . 4
ISO MOUNT . . . . . . . . . . . . . . . . . . 4
WASHER/CANOPY MOUNT. . . . . . 2
7/8”-9 CLASS C LOCK NUT . . . . . . 4
3/8”-16X2-1/2” HX GR5 . . . . . . . . . . 4
RETAINER/CANOPY NUT . . . . . . . 2
BREATHER . . . . . . . . . . . . . . . . . . . 2
PLUG/HOLE 2.25”. . . . . . . . . . . . . . 2
PANEL/ACCESS BREATHER . . . . . 1
(Yellow Cab)
(Gray Cab)
FUSE/RELAY BOX . . . . . . . . . . . . . 1
CHANGE OVER RELAY . . . . . . . 10
FLASHER UNIT . . . . . . . . . . . . . . . 1
WIRE ASY . . . . . . . . . . . . . . . . . . . 7
CONNECTION BRIDGE. . . . . . . . . 2
5 A ATC FUSE . . . . . . . . . . . . . . . . 4
10 A ATC FUSE . . . . . . . . . . . . . . . 4
20 A ATC FUSE . . . . . . . . . . . . . . . 4
30 A FUSE . . . . . . . . . . . . . . . . . . . 4
60 A FUSE . . . . . . . . . . . . . . . . . . . 4
TRIM/DIVIDER . . . . . . . . . . . . . . . . 1
RETAINER WASHER . . . . . . . . . . . 2
1/2” FLAT WASHER . . . . . . . . . . . AR
1/2”-13X1-1/4” BOLT GR5 HX . . . AR
FRONT GUARD . . . . . . . . . . . . . . . 1
(note a, b and c)
(note d and e)
HEAD LIGHT . . . . . . . . . . . . . . . . . . 2
HEAD LIGHT HARNESS . . . . . . . . 2
GROMMET, 11/16” ID 1-5/16” OD . 2
GROMMET, 3/8” ID 13/16”OD. . . AR
GROMMET, 3/8” ID 3/4” OD . . . . AR
SCREW/FLANGE . . . . . . . . . . . . . AR
CLIP/WINDOW BLACK . . . . . . . . AR
GLASS/RH SIDE . . . . . . . . . . . . . . . 1
(note a, b and c)
(note d and e)
SCREEN (option) (note a, b and c)
SCREEN (option) (note d and e)
BULBSEAL/RH SIDE WINDOW . . . 1
(note a, b and c)
(note d and e)
FOPS WELDMENT (bolt on) . . . . . . 1
00
00de
00de
00
L500064
L500080
L500081
088296
-- ITEMS NOT SHOWN -PLUG/HOLE,.5" BLACK . . . . . . . . . 1
BRKT/STEER COLUMN FRONT . . 1
WLDMT/STEER BRKT REAR. . . . . 1
STROBE LIGHT (option) . . . . . . . . . 1
02
03
04
05
06
07
08
09
10
13
14de
15
16
17
18
19
20
21
22
L500969
101418
101972
101974
L50300
L69115
101487
L50301
L50371
101667
L70388
L70017
L99974
101902
L69137
L70075
L70123
L70121
101356
L70244
L70245
L70246
L70247
L500225
101774
L69729
L50151
L50283
L70471
101767
L70039
L70241
101711
101712
L70463
L500055
L500057
L500069
101714
L71223
101704
23
PRINTED IN U.S.A.
Ref.
No.
00
00abc
00abc
00de
Part
No.
L500060
L500244
L500245
101716
00
L70403
L71146
L71351
101443
00
L70406
L71341
Description
Qty.
Req.
DECAL/ROPS/FOPS WARN. . . . . . 1
HEADLINER FOAM. . . . . . . . . . . . . 1
HEADLINER . . . . . . . . . . . . . . . . . . 1
HEADLINER . . . . . . . . . . . . . . . . . . 1
(Wiring Harness)
CANOPY WIRE HARNESS. . . . . . . 1
(note a)
(note b)
(note c)
(note d and e)
FRAME WIRE HARNESS . . . . . . . . 1
(note a and b)
(note c, d and e)
These units may
also require updating of switches to
current style; consult factory for
details.
a
b
DL6H SN 20300 Thru SN 20576
DL6L SN 25352 Thru SN 25498
DL10H SN 40136 Thru SN 40261
DL10L SN 45098 Thru SN 45135
c
DL10H SN 40262 Thru SN 40468
DL10L SN 45135 Thru SN 45172
DL12H SN 50130 Thru SN 50199
d
DL10H SN 40469 Thru SN 40498
DL10L SN 45173 Thru SN 45184
e
21
907878/DP0208
DL Series Dynalift
Cab (Part 2 of 3)
Early Style Cab
(shown)
1
2
3
4
5
23
21
22
20
6
7
19
8
16
9
15
Early Style Cab
10
17
18
16
11
Later Style Cab
Storage Door
14
15
12
13
14
907878/DP0208
22
Early Style Cab
Storage Door
PRINTED IN U.S.A.
DL Series Dynalift
Cab (Part 2 of 3)
Ref.
No.
Part
No.
01ab
02ab
L500077
L70055
L70116
03ab
04ab
05
06ab
07ab
08ab
09ab
10ab
11ab
12ab
13ab
14
15
16
17cd
18cd
L500078
L500228
L70116
L99843
L500059
L500075
L70486
L99843
L500548
L500076
L500052
L500082
L500067
L500124
L500125
L99157
L500049
650697
101773
101772
101914
101774
19
L500072
101721
20
21
22ab
23
L500071
101720
L500070
L500169
L63548
Description
Qty.
Req.
Ref.
No.
JOYSTICK BRACKET . . . . . . . . . . . 1
LOWER FRONT COVER . . . . . . . . 1
M6-12X1 SCREW. . . . . . . . . . . . . . 4
LOWER REAR COVER. . . . . . . . . . 1
Note a
Note b
M6-12X1 SCREW . . . . . . . . . . . . AR
RECTANGULAR LOUVER . . . . . . . 1
FIXED VANE LOUVER. . . . . . . . . AR
DECK MAT RETAINER . . . . . . . . . . 1
1/4”-20x1” TORX BOLT . . . . . . . . AR
REAR DECK MAT . . . . . . . . . . . . . . 1
STORAGE COMPARTMENT LID . . 1
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
DOOR STRIKER . . . . . . . . . . . . . . . 1
STORAGE DOOR . . . . . . . . . . . . . . 1
PADDLE LATCH . . . . . . . . . . . . . . . 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
3/8-16 LOCK NUT . . . . . . . . . . . . . . 2
3/8-16X6 BOLT . . . . . . . . . . . . . . . . 2
BULB SEAL/STORAGE DOOR. . . . 1
STORAGE DOOR . . . . . . . . . . . . . . 1
(Yellow Cab)
(Gray Cab)
TRIM/DIVIDER
FLOOR MAT . . . . . . . . . . . . . . . . . . 1
(note a and b)
(note c and d)
FLOOR MAT RETAINER . . . . . . . . . 1
(note a and b)
(note c and d) . . . . . . . . . . . . . . . . . .
FLOAT GAUGE COVER . . . . . . . . . 1
BRACKET, STRIKER . . . . . . . . . . . 1
STRIKER . . . . . . . . . . . . . . . . . . . . . 1
Part
No.
Description
a
b
DL8H SN 30229 Thru SN30820
DL10H SN 40104 Thru SN 40468
DL10L SN 45085 Thru SN 45172
c
DL10H SN 40469 Thru SN 40498
DL10L SN 45173 Thru SN 45184
d
Qty.
Req.
Note: refer to the section “Dash/Tilt Plastic Housing
Group (Part 2 of 2)” for interior plastic parts for later
style cabs including: rear deck, joystick console,
panels,etc.
PRINTED IN U.S.A.
23
907878/DP0208
DL Series Dynalift
Cab (Part 3 of 3)
FRONT
1
4
2
5
7
3
8
6
Right Side Mirror
Left Side Mirror
(option)
FRONT
9
Dome Light
Defroster Fan
11
12
13
10
Level Indicator
15 14
16
23
22
21
20
19
18
17
Diode Packs
907878/DP0208
24
PRINTED IN U.S.A.
DL Series Dynalift
Cab (Part 3 of 3)
Ref.
No.
Part
No.
Description
Qty.
Req.
102962
102963
L63756
(Left Side Mirror - Option)
MIRROR MOUNT . . . . . . . . . . . . . . 1
BAR, MIRROR MOUNT . . . . . . . . . 1
MIRROR . . . . . . . . . . . . . . . . . . . . . 1
04
05
06
07
08
L70417
L70345
L50081
L70344
L50105
(Right Side Mirror)
SIDE MIRROR. . . . . . . . . . . . . . . . . 1
MIRROR BAR (Mirror End) . . . . . . . 1
5/8”-11 NUT . . . . . . . . . . . . . . . . . . . 1
MIRROR BAR (Base End) . . . . . . . 1
1-1/8” JAM NUT` . . . . . . . . . . . . . . . 1
09a
10a
103159
137497
103160
103161
(Dome Light)
WLDMNT/DOME LIGHT MOUNT . . 1
DOME LIGHT . . . . . . . . . . . . . . . . . 1
HARNESS, INTERIOR LIGHT . . . . 1
HARNESS, DOME LIGHT GRND . 1
L66986
L50208
L66993
L50896
L50655
101158
L70463
(Defroster Fan)
DEFROSTER FAN . . . . . . . . . . . . . 1
1/4”-20X1/2” SELF TAPSCREW . . . 2
BRACKET, DEFROSTER FAN . . . . 1
#10-24 NUT . . . . . . . . . . . . . . . . . . . 3
#10-24 BOLT . . . . . . . . . . . . . . . . . . 3
HARNESS/DEFROSTER FAN . . . . 1
GROMMET, 3/8”ID 3/4”OD . . . . . AR
01a
02a
03a
Ref.
No.
PRINTED IN U.S.A.
Qty.
Req.
21
22
23
L66011
L69297
00
(Strobe Light [option] - Not Shown)
104952
STROBE, AMBER . . . . . . . . . . . . . . 1
19
20
a
25
Description
(Wiring Harness - Diode Packs)
L500748
DIODE PACK, 3 DIODES. . . . . . . AR
(72-50-286 )
Imprinted on diode pack.
103104
(72-50-285 REV A )
103101
(72-50-285 )
L500569
(72-50-283)
L500747
CLEAR COVER, DIODE PACK . . AR
17
18
11
12
13
14
15
16
Part
No.
(Level Indicator)
LEVEL INDICATOR . . . . . . . . . . . . . 1
LEVEL INDICATOR MOUNT. . . . . . 1
Designed for units with these serial numbers:
907878/DP0208
DL Series Dynalift
Front Glass
FRONT
1
10
11 12
13
14
9
8
6
6
5
7
4
Early Style
2
3
Later Style
907878/DP0208
26
PRINTED IN U.S.A.
DL Series Dynalift
Front Glass
Ref.
No.
Part
No.
01
L500032
101726
02
03c
04
05
06
07
08
09
10
11
12
13
14
L500109
L500713
101725
L500030
L50486
L50139
L50137
L500031
L50486
L50139
L50137
L500025
L500028
L500019
L500027
L500019
L70486
L500111
L500020
L500021
L500022
L500017
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
Note a and b
Note c
FRONT GLASS . . . . . . . . . . . . . . . . 1
Note a
Note b
FRONT GLASS . . . . . . . . . . . . . . . . 1
HOLD OPEN BRACKET . . . . . . . . . 1
1/4”-20X5/8” BOLT . . . . . . . . . . . . . 2
1/4” LOCK WASHER . . . . . . . . . . . 2
1/4” FLAT WASHER . . . . . . . . . . . . 2
1/4”-20X5/8” BOLT . . . . . . . . . . . . . 2
1/4” LOCK WASHER . . . . . . . . . . . 2
1/4” FLAT WASHER . . . . . . . . . . . . 2
DETENT RING PIN . . . . . . . . . . . . . 2
L STYLE HOLD OPEN (LH) . . . . . . 1
ROLL PIN 3/16”X1/2” . . . . . . . . . . . 1
L STYLE HOLD OPEN (RH) . . . . . . 1
ROLL PIN 3/16”X1/2” . . . . . . . . . . . 1
1/4”-20X1” TORXSCREW . . . . . . . . 2
FRONT WINDOW HINGE . . . . . . . . 2
NYLON BUSHING 1/4” ID. . . . . . . . 2
GROMMET 1/2” ID . . . . . . . . . . . . . 2
FLATWASHER. .28” ID . . . . . . . . . . 2
1/4”-20 ACORN NUT BLACK . . . . . 2
00c
27
Part
No.
Description
Qty.
Req.
(Complete Front Window Assembly)
101764
COMPLETE ASSEMBLY . . . . . . . . . 1
(includes all items shown, except
item 3; as well as wiper motor,
wiper blade and related wiper parts)
a
b
DL10H SN 40435 Thru SN 40468
DL10L SN 45172 Thru SN 45172
DL12H SN 50193 Thru SN 50199
c
907878/DP0208
DL Series Dynalift
Windshield Wiper - Front
1
2
3
8
17
18
7
19
9
4
6
16
15
14
12
11
13
12
11
5
10
WASHER SYSTEM RESERVOIR
LOCATED INSIDE ENGINE HOOD
NEXT TO RADIATOR
20
907878/DP0208
28
PRINTED IN U.S.A.
DL Series Dynalift
Windshield Wiper - Front
Ref.
No.
Part
No.
01
02bc
03d
04
05
06
07
08
09
10
11
12
13
14
15
16
L500102
L500703
L500707
L500101
L500702
L500700
L500706
L500709
L500697
L500099
L500101
L500719
L500711
101717
L500694
L500004
L500110
L500696
L500001
L500112
L500718
17
18
19
L99848
L500695
L500701
L500108
L500712
L500708
20
L70649
101495
Description
Qty.
Req.
Ref.
No.
WIPER BLADE . . . . . . . . . . . . . . . . 1
Note a (20”)
Note b and c (20”)
ADAPTER / PIN LOCK . . . . . . . . . . 1
WIPER ARM . . . . . . . . . . . . . . . . . . 1
Note a (included with #9 - note a)
Note b and c (15-1/2”)
M8 / ACORN NUT . . . . . . . . . . . . . . 1
M5 / ACORN NUT . . . . . . . . . . . . . . 1
RAIN SHIELD . . . . . . . . . . . . . . . . . 1
M18 / NUT . . . . . . . . . . . . . . . . . . . . 1
ADAPTER/WET ARM . . . . . . . . . . . 1
PANTO ADAPTER PLATE. . . . . . . . 1
Note a (included with #3 - note a)
Note b and c
SCREW / M5 16mm . . . . . . . . . . . . 1
WASHER, #10 WEATHERTITE . . . 2
BUSHING / NYLON. . . . . . . . . . . . . 2
NUT/ACORN #10-24 BLK . . . . . . . . 1
COVER WIPER MOTOR. . . . . . . . . 1
Note a
Note b and c
WASHER/BLK NYLON. . . . . . . . . AR
FASTENER . . . . . . . . . . . . . . . . . . . 1
Note a (#10-32x7/8” screw)
Note b and c (#10-24x1-1/4” bolt)
WIPER MOTOR. . . . . . . . . . . . . . . . 1
Note a and e
Note b and c
GASKET / PANTO ADAPTER . . . . . 1
TOWER SEAL / WIPER . . . . . . . . . 1
Note a (nylon spacer 5/16” ID)
Note b (glass with 3/4” ID)
Note b and c (glass with 1” ID)
WASHER BOTTLE, W/PUMP(S) . . 1
SINGLE PUMP
DUAL PUMP
00a
00
00
Part
No.
Description
Qty.
Req.
-- ITEMS NOT SHOWN -(Wet arm kit)
L500106
WET ARM KIT . . . . . . . . . . . . . . . . . 1
(when not included with wiper arm)
(Windshield Wiper Harness)
HARNESS, FRONT WIPER . . . . . . 1
L500113
Note a
L500715
Note b
(Windshield Washer System)
L70709
HARNESS, WASHER BOTTLE . . AR
a
b
DL10H SN 40435 Thru SN 40468
DL10L SN 45172 Thru SN 45172
DL12H SN 50193 Thru SN 50199
c
d
PN L500702 has a built in washer spray nozzle
and hose (wet arm).
PN L500101 does not come with the washer spray
nozzle and hose (wet arm); order L500106 Wet
Arm Kit if needed.
e
PRINTED IN U.S.A.
29
It is recommended to order wiper kit L500749.
907878/DP0208
DL Series Dynalift
Top Glass and Wiper (Early Style)
4
3
2
5
6
1
11
7
12
8
13
9
14
10
15
16
1
17
18
19
20
21
Reference for sealant
907878/DP0208
30
PRINTED IN U.S.A.
DL Series Dynalift
Top Glass and Wiper (Early Style)
Ref.
No.
Part
No.
01
02b
03
04
05
06
07
08
09a
09b
10
11b
12b
13b
14b
15
16
L500011
L500714
L500680
L500009
L500705
L500008
L500002
L500704
L500016
L500004
L500001
L500104
L500114
L500717
L500014
L500716
L500709
L500697
L500699
L500698
L500108
L500712
L500708
L500013
L500013
L500710
17
L500750
L500695
Description
Qty.
Req.
Ref.
No.
TOP GLASS . . . . . . . . . . . . . . . . . . 1
Note a
Note b
NUT, M8 HEX (Trico motor). . . . . . . 1
RADIAL WIPER ARM . . . . . . . . . . . 1
Note a
Note b
WET ARM KIT . . . . . . . . . . . . . . . . . 1
WIPER BLADE, 20”. . . . . . . . . . . . . 1
Note a
Note b
HOSE REDUCER . . . . . . . . . . . . . . 1
#10-24 ACORN NUT . . . . . . . . . . . 1
FLATWASHER. .26”ID. . . . . . . . . . . 1
RUBBER WASHER. .187”ID . . . . . . 1
NYLON BUSHING 1/4”ID . . . . . . . . 1
GROMMET, T-STYLE RUBBER . . . 1
TOP WINDOW WIRE HARNESS . . 1
Note a
Note b
RAIN SHIELD . . . . . . . . . . . . . . . . . 1
NUT, M18 HEX . . . . . . . . . . . . . . . . 1
WASHER, STEEL M18 . . . . . . . . . . 1
WASHER, FIBER M18 . . . . . . . . . . 1
NYLON SPACER . . . . . . . . . . . . . . 1
Note a (3/4” ID)
Note b and c
Note b and c
WIPER MOTOR COVER. . . . . . . . . 1
Note a (Included with item 18 note a)
Note b
WIPER MOTOR. . . . . . . . . . . . . . . . 1
Note a (replacement kit for L99848)
Note b
Part
No.
18
L500013
L500696
19
20
21
22d
L500006
L500001
L500718
L500607
L500005
L70649
L70709
Description
Qty.
Req.
WIPER MOTOR COVER. . . . . . . . . 1
Note a (Included with item 16 note a)
Note b
ROUND HEAD SCREW. . . . . . . . . 1
Note a (#10-24X7/8”)
FLATWASHER. .26”ID . . . . . . . . . . 1
Note b (#10-24X1-1/14”)
GLUE KIT . . . . . . . . . . . . . . . . . . . . 1
SETTING BLOCK . . . . . . . . . . . . . . 8
WASHER BOTTLE, W/PUMP . . . . . 1
WASHER WIRE HARNESS . . . . . . 1
a
b
DL10H SN 40435 Thru SN 40468
DL10L SN 45172 Thru SN 45172
DL12H SN 50193 Thru SN 50199
c
Use L500712 for glass with 3/4” diameter hole.
Use L500708 for glass with 1” diameter hole.
d
Washer bottle has one pump. Refer to next
page if washer bottle has two pumps.
NEXT TO RADIATOR
22
PRINTED IN U.S.A.
31
907878/DP0208
DL Series Dynalift
Top Glass and Wiper (Later Style)
6
7
5
8
9
3
4
10
2
11
12
13
1
14
10
15
16
17
18
907878/DP0208
32
PRINTED IN U.S.A.
DL Series Dynalift
Top Glass and Wiper (Later Style)
Ref.
No.
Part
No.
01a
101723
L500607
L500703
L500707
L500099
101718
L500700
L500706
L500709
L500711
101717
L500697
L500719
L500004
L500701
L500695
02a
03a
04a
05ab
06a
07a
08a
09a
10a
11a
12a
13a
14a
15a
Description
Qty.
Req.
Ref.
No.
Part
No.
GLASS, SKYLIGHT CURVED. . . . . 1
GLUE KIT . . . . . . . . . . . . . . . . . . . AR
WIPER BLADE / 20" . . . . . . . . . . . . 1
ADAPTER/PIN LOCK . . . . . . . . . . . 1
ADAPTER/WET ARM . . . . . . . . . . . 1
ARM, WIPER 24" WET PANTO . . . 1
NUT / M8 PANTO PLATE . . . . . . . . 1
NUT / M5 ACORN . . . . . . . . . . . . . . 1
RAIN SHIELD . . . . . . . . . . . . . . . . . 1
SCREW / M5 16MM . . . . . . . . . . . . 1
WASHER, #10 WEATHERTITE . . AR
NUT M18 HEX. . . . . . . . . . . . . . . . . 1
PANTO ADAPTER PLATE. . . . . . . . 1
NUT/ACORN #10-24 BLK . . . . . . . . 1
GASKET / PANTO ADAPTER . . . . . 1
WIPER MOTOR / TRICO . . . . . . . . 1
16a
17a
18a
19c
L500696
L500001
L500718
101495
103912
Description
Qty.
Req.
COVER WIPER MOTOR. . . . . . . . . 1
WASHER/BLK NYLON . . . . . . . . . . 1
#10-24x1.25 BOLT GR5 . . . . . . . . . 1
WASHER BOTTLE, W/PUMPS. . . . 1
TOP WIPER HARNESS . . . . . . . . . 1
(includes top washer hose)
a
b
Windshield washer spray nozzle is incorporated into
wiper arm and is not sold separately.
c
Washer bottle with two pumps.
Early style (PN L70649) had one pump; refer to
previous page for early style washer system.
NEXT TO RADIATOR
19
PRINTED IN U.S.A.
33
907878/DP0208
DL Series Dynalift
Left Glass (Early Style)
(Refer to Usage Table below)
2
1
3
4
Ref.
No.
00
01
02
03
04
Part
No.
L500117
L500033
L500032
L500057
L500055
907878/DP0208
Description
Qty.
Req.
Ref.
No.
LEFT REAR GLASS . . . . . . . . . . . . 1
BULB SEAL 1/4” CLIP ON . . . . . . . 1
WINDOW CLIP . . . . . . . . . . . . . . . . 5
#10-16X1.75 FLNG SCREW . . . . . 10
Part
No.
Description
Qty.
Req.
Usage Table
Parts listed on this page apply to the following units:
34
PRINTED IN U.S.A.
DL Series Dynalift
Left Glass (Later Style)
1
2
3
4
5
8
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
101724
101722
101715
L500017
L500021
L500020
L500022
101733
PRINTED IN U.S.A.
7
6
Description
Qty.
Req.
Ref.
No.
GLASS LH SIDE . . . . . . . . . . . . . . . 1
BULBSEAL, LH REAR WINDOW . . 1
CLIP, Z . . . . . . . . . . . . . . . . . . . . . . . 4
1/4”-20 NUT/ACORN BLK . . . . . . . . 4
GROMMET/.50 ID .25 GROOVE . . 4
BUSHING/NYLON . . . . . . . . . . . . . . 4
WASHER/FLAT BLACK. . . . . . . . . . 4
1/4”-20x7/8” TRS TX . . . . . . . . . . . . 4
Part
No.
Description
Qty.
Req.
Usage Table
35
907878/DP0208
DL Series Dynalift
Rear Glass (Early Style)
FRONT
10
1
5
6
8
16
4
2
12
9
3
11
7
9
14
17
19
13
3
7
15
907878/DP0208
18
19
18
17
36
PRINTED IN U.S.A.
DL Series Dynalift
Rear Glass (Early Style)
Ref.
No.
00
01
02
03
04
05
06
07
08
Part
No.
L500116
L500017
NSS
L70486
L500019
L500020
L500021
L500022
L500023
L500024
Description
Qty.
Req.
1/4”-20 ACORN NUT . . . . . . . . . . . . 2
BLUE LOCKTITE® . . . . . . . . . . . AR
1/4”-20X1” TORX SCREW. . . . . . . . 2
ROLL PIN 3/16X1/2. . . . . . . . . . . . . 2
NYLON BUSHING 1/4”ID . . . . . . . . 2
GROMMET 1/2”ID . . . . . . . . . . . . . . 2
FLATWASHER. .28”ID. . . . . . . . . . . 2
FLATWASHER. 1/4”ID. . . . . . . . . . . 2
PLASTIC HINGE . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
09
10
11
12
13
14
15
16
17
18
19
L500025
L500026
L500027
L500028
L500029
L500030
L500031
L50328
L50486
L50139
L50137
Description
Qty.
Req.
DETENT RING PIN .188” . . . . . . . . 2
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
RH HOLD OPEN . . . . . . . . . . . . . . . 1
LH HOLD OPEN . . . . . . . . . . . . . . . 1
REAR GLASS . . . . . . . . . . . . . . . . . 1
1/4”-20X3/4” TORX SCREW . . . . . . 4
1/4”-20X5/8” GR5 BOLT . . . . . . . . . 4
1/4” LOCK WASHER . . . . . . . . . . . . 4
1/4” FLAT WASHER . . . . . . . . . . . . 4
Usage Table
PRINTED IN U.S.A.
37
907878/DP0208
DL Series Dynalift
Rear Glass (Later Style)
9
3
15
11
7
2
6
8
1
12
13
10
5
4
14
FRONT
907878/DP0208
38
PRINTED IN U.S.A.
DL Series Dynalift
Rear Glass (Later Style)
Ref.
No.
00
01
02
03
04
05
06
07
Part
No.
101761
L500017
L70486
101732
L500019
101727
L500020
L500021
Description
Qty.
Req.
1/4”-20 NUT/ACORN BLK . . . . . . . . 2
1/4”-20x1” BOLT BLK . . . . . . . . . . . 2
1/4”-20x1-1/4” TRS G5 ES5BF . . . . 4
PIN/ROLL . . . . . . . . . . . . . . . . . . . . 1
HOLD OPEN, WINDOW T-STYLE . 1
BUSHING/NYLON . . . . . . . . . . . . . . 2
GROMMET, 1/2”ID 1/4” GROOVE . 2
Ref.
No.
Part
No.
08
09
10
11
12
13
14
15
L500022
L500024
L500025
101790
101728
101729
101730
101731
Description
Qty.
Req.
HINGE/PLASTIC . . . . . . . . . . . . . . . 2
PIN/DETENT RING . . . . . . . . . . . . . 1
GASKET . . . . . . . . . . . . . . . . . . . . . 2
GLASS, REAR WINDOW . . . . . . . . 1
BULBSEAL, REAR WINDOW . . . . . 1
MOUNT, REAR WINDOW LATCH . 1
HINGE BLOCK . . . . . . . . . . . . . . . . 2
Usage Table
PRINTED IN U.S.A.
39
907878/DP0208
DL Series Dynalift
Upper Door (Early Style)
10
6
15
8
11
9
6
13
12
14
4
17
16
15
10
6
13
18
3
6
7
5
19
9
8
14
2
4
1
Attaches to cab
Attaches to door
5
907878/DP0208
40
PRINTED IN U.S.A.
DL Series Dynalift
Upper Door (Early Style)
Ref.
No.
Part
No.
00a
L500355
01
02
03
04
05d
06
07
08
09
10
11
12
13
14
15
16
L500355
L500360
L500607
L500039
L500355
L500359
L500043
L500036
L500021
L500034
L500022
L500020
L500040
L500269
L500268
L500042
L500037
L500038
L500046
Description
Qty.
Req.
(Includes items 1 and 3 - note c)
UPPER DOOR GLASS . . . . . . . . . . 1
Note b; includes item 3, note c.
Note c
GLUE KIT . . . . . . . . . . . . . . . . . . . . 1
UPPER DOOR BULB SEAL . . . . . . 1
UPPER DOOR FRAME. . . . . . . . . . 1
Note b. Includes item 1 note c.
Note c
HINGE . . . . . . . . . . . . . . . . . . . . . . . 2
DOOR HOLD OPEN . . . . . . . . . . . . 1
GROMMET . . . . . . . . . . . . . . . . . . . 4
1/4”-20X1-3/4” BOLT . . . . . . . . . . . . 1
1/4” FLAT WASHER . . . . . . . . . . . . 2
NYLON BUSHING. . . . . . . . . . . . . . 2
1/4”-20 NUTSERT . . . . . . . . . . . . . . 2
1/4”-20X2” TORX HD SCREW . . . . 1
RUBBER BUMPER . . . . . . . . . . . . . 1
STEEL BUSHING . . . . . . . . . . . . . . 2
5/16”-18X2” TRUSS HD SCREW . . 2
5/16”-18 ACORN NUT . . . . . . . . . . . 2
STRIKER . . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
17
18
19
L500017
L500023
L500041
a
Replaces older style upper door and glass
b
Description
Qty.
Req.
1/4”-20 ACORN NUT . . . . . . . . . . . . 2
FLAT WASHER . . . . . . . . . . . . . . . . 2
1/4”-20X1-1/2” HEX HD SCREW . . 2
--- SERIAL NUMBERS --DL6H SN 20556 and before
c
DL6H SN 20557 Thru SN20797
DL10H SN 40253 Thru SN 40468
DL10L SN 45135 Thru SN 45172
DL12H SN 50129 Thru 50199
d
Includes both components, one attaches to door,
the other attaches to the cab; they are not sold
separately.
Usage Table
PRINTED IN U.S.A.
41
907878/DP0208
DL Series Dynalift
Upper Door (Later Style)
11
10
16
6
20
17
18
19
8
6
13
9
21
1
15
7
3
4
16
2
14
5
8
18
17
6
13
9
12
Attaches to cab
Attaches to door
3
907878/DP0208
42
PRINTED IN U.S.A.
DL Series Dynalift
Upper Door (Later Style)
Ref.
No.
Part
No.
00
01
02
03a
04
05
06
07
08
09
10
11
12
13
14
101763
101907
L500034
L500017
L500036
101753
L500020
L500021
L500114
L500037
L500038
101754
101709
101755
101743
101756
Description
Qty.
Req.
(Yellow Cab)
(Gray Cab)
SCREW/HEX . . . . . . . . . . . . . . . . . . 1
NUT/ACORN .25-20 BLK . . . . . . . . 1
HOLD OPEN/DOOR (set) . . . . . . . . 1
NUT, HEX M6x1 YZ DR 10.9 . . . . . 2
BUSHING/NYLON . . . . . . . . . . . . . . 1
GROMMET/.50id .25 GROOVE . . . 3
BUSHING/NYLON-WHITE . . . . . . . 1
BOLT/BLK TRUSS HEAD . . . . . . . . 2
NUT/ACORN BLACK . . . . . . . . . . . 2
BOLT, .38-16x4.5 HEX 304 SS . . . . 1
BUMPER, RUBBER 2" CONE . . . . 1
BOLT, M6x1x25 FLT PH ES5YZ . . . 3
NUT, .38-16 HEX TL-316SS . . . . . . 2
LATCH, ROTARY RIGHT . . . . . . . . 1
Ref.
No.
Part
No.
15
16
17
18
101757
101719
L500042
101750
101909
19
20
21
a
101758
101910
L500967
L500607
101759
Description
Qty.
Req.
BLT, .38-16x8.5 HEX SS . . . . . . . . . 1
GLASS MOUNT . . . . . . . . . . . . . . . 2
BUSHING/STEEL . . . . . . . . . . . . . . 2
HINGE, DOOR . . . . . . . . . . . . . . . . 2
(Yellow Cab)
(Gray Cab)
WLDMNT, UPPER DOOR . . . . . . . . 1
(Yellow Cab)
(Gray Cab)
GLASS, UPPER DOOR . . . . . . . . . 1
GLUE KIT . . . . . . . . . . . . . . . . . . . 1
BULBSEAL, UPPER DOOR . . . . . . 1
Includes both components, one attaches to door,
the other attaches to the cab; they are not sold
separately.
Usage Table
PRINTED IN U.S.A.
43
907878/DP0208
DL Series Dynalift
Lower Door (Early Style)
SEE DETAIL “A”
DETAIL “A”
13
13
8
9
2
11
12
9
7
3
6
SEE DETAIL “A”
12
14,15
16
4
10
17
5
18
1
907878/DP0208
44
PRINTED IN U.S.A.
DL Series Dynalift
Lower Door (Early Style)
Ref.
No.
00
01
02
03
04
05
06
07
08
Part
No.
L500120
L500082
L500083
L500084
651574
166776
L500086
L66907
L50212
L500087
L500088
L500089
L99157
Description
Qty.
Req.
COMPLETE. ASSEMBLY. . . . . . . . . 1
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
1/4-20X3/4 TRUSS HD SCREW . . . 4
#10-24X1/2 TRUSS HD SCREW . . 6
#8-32x1-1/8” SOCKT HD SCREW . 1
#8-32 NUT . . . . . . . . . . . . . . . . . . . . 1
RELEASE LEVER . . . . . . . . . . . . . . 1
INSIDE DOOR HANDLE . . . . . . . . 1
#10-24X1/4” SET SCREW . . . . . . . 1
LH INSIDE HANDLE ASY. . . . . . . . 1
RH ROTARY LATCH . . . . . . . . . . . . 1
PADDLE LATCH . . . . . . . . . . . . . . . 1
KEY/CAB (CH751) . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
09
10
11
12
13
14
15
16
17
18
L500090
L500091
L500092
L500093
L500094
L500095
NSS
L500096
L500097
L70116
Description
Qty.
Req.
INTERNAL.TOOTH RETAINER . . . 3
LH DRIVE BAR WELD. . . . . . . . . . . 1
LOWER DOOR WELD. . . . . . . . . . . 1
DOOR RELEASE ROD . . . . . . . . . . 1
DOOR LATCH SHORT ROD. . . . . . 1
DOOR CARPET . . . . . . . . . . . . . . . 1
CONTACT ADHESIVE . . . . . . . . . AR
SLAM LATCH WELD. . . . . . . . . . . . 1
DOOR PLASTIC . . . . . . . . . . . . . . . 1
M6-12X1 SCREW . . . . . . . . . . . . . . 9
Usage Table
PRINTED IN U.S.A.
45
907878/DP0208
DL Series Dynalift
Lower Door (Later Style)
24
2
23
5
20
12
15
23
21
6
20
2
14
3
18
10
19
5
8
16
13
6
25
11
1
17
4
2
7
9
26
27
28
22
907878/DP0208
46
PRINTED IN U.S.A.
DL Series Dynalift
Lower Door (Later Style)
Ref.
No.
Part
No.
00
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
101762
101906
L500017
L500021
L500022
101737
L500037
L500038
101709
101738
101739
101740
101741
101742
101743
101710
101744
101792
101745
101746
Description
Qty.
Req.
(Yellow Cab)
(Gray Cab)
1/4”-20 NUT/ACORN BLK . . . . . . . . 1
GROMMET/.50ID .25 GROOVE . . . 3
SCR, M6x1x12 FLG YZD . . . . . . . . 2
BOLT/BLK TRUSS HEAD . . . . . . . . 2
NUT/ACORN BLACK . . . . . . . . . . . 2
BUMPER, RUBBER 2" CONE . . . . 1
M12x1 HEX BOLT ES5CZ. . . . . . . . 1
M8x1.25x35 BOLT . . . . . . . . . . . . . . 2
1/2”x1-1/4”X.083” FLT WASHER Z . 1
M8x1.25 HEX NUT NK ES5CZ . . . . 2
3/8”-16x5” BOLT . . . . . . . . . . . . . . . 1
38”-16 HEX NUT TL-316SS . . . . . . 1
STRIKER, M12x1x25 . . . . . . . . . . . 1
HANDLE, EXT. DOOR LOCKING . . 1
KEY ONLY
M5x.8x20 BOLT PAN PH . . . . . . . . 1
COVER, GRAB HANDLE LATCH . . 1
Ref.
No.
Part
No.
18
19
20
21
22
101747
101748
L500042
L500966
Description
Qty.
Req.
101750
101909
BUMPER, RECESS . . . . . . . . . . . . 1
CAM LATCH, LH . . . . . . . . . . . . . . . 1
BUSHING/STEEL . . . . . . . . . . . . . . 2
GLASS, LOWER DOOR . . . . . . . . . 1
WLDMNT, LOWER DOOR . . . . . . . 1
(Yellow Cab)
(Gray Cab)
HINGE, LOWER DOOR . . . . . . . . . 2
(Yellow Cab)
(Gray Cab)
24
25
26
27
28
101751
101752
101793
L500098
101794
BULBSEAL, LOWER DOOR . . . . . . 1
INSIDE SEAL, LOWER DOOR . . . . 1
M8X20 BOLT HEX FLNG HD . . . . . 1
WASHER/BLK NYLON . . . . . . . . . . 1
M8 HEX NUT YZ . . . . . . . . . . . . . . . 1
00
L500607
-- ITEMS NOT SHOWN -GLUE KIT . . . . . . . . . . . . . . . . . . . . 1
101749
101912
23
Usage Table
PRINTED IN U.S.A.
47
907878/DP0208
DL Series Dynalift
Dash (Early Style)
15
13
11
18
21
2
16,17
12
14
29
19
10
1
9
3
5
7
20
2
22
4
6
8
24
25
26
31
28
30
27
23
907878/DP0208
48
PRINTED IN U.S.A.
DL Series Dynalift
Dash (Early Style)
Ref.
No.
Part
No.
01
L71681
L70116
02
L70710
L71095
L71709
L70486
L52027
03
L69282
L71075
04
L70414
L71085
05
06
L69290
L71082
L71077
L69284
L71077
07
L70031
L71084
08
09
10
11
12
L69300
L71083
089069
089070
L41848
L71088
L69289
L71081
13
L70416
L71086
14
L69283
L71076
15
L69285
L71078
16
L69287
L71080
17
L69286
L71079
18
19
L69281
L71074
L69402
L63887
L50051
PRINTED IN U.S.A.
Description
Qty.
Req.
FRONT DASH PLASTIC . . . . . . . . . 1
Note d and Note e
M6-12X1 SCREW. . . . . . . . . . . . . . 8
SWITCH MOUNT PLATE . . . . . . . . 2
Note a - (6 holes)
Note b - (6 holes)
Note b - (7 holes)
1/4”-20X1” TORX SCREW . . . . . . . 2
WELD NUT 1/4-20 . . . . . . . . . . . . . 2
STEER MODE SWITCH . . . . . . . . . 1
Note a
Note b
AXLE ALIGN SWITCH. . . . . . . . . . . 1
Note a
Note b
LIGHTS SWITCH . . . . . . . . . . . . . . 1
Note a and f
Note b and c
HAZARD SWITCH. . . . . . . . . . . . . . 1
Note a and f
Note b and c
TURN SIGNAL SWITCH . . . . . . . . . 1
Note a and f
Note b and c
BEACON SWITCH . . . . . . . . . . . . . 1
Note a and f
Note b and c
START SWITCH . . . . . . . . . . . . . . . 1
KEY ONLY . . . . . . . . . . . . . . . . . . . 1
START PUSH BUTTON . . . . . . . . . 1
SWITCH HOLE PLUG . . . . . . . . . AR
ETHER SWITCH . . . . . . . . . . . . . . 1
Note a and f
Note b and c
CLUTCH CUT-OUT SWITCH . . . . . 1
Note a
Note b
WIPER/WASHER SWITCH . . . . . . . 1
Note a and f
Note b and c
FAN SPEED SWITCH . . . . . . . . . . . 1
Note a and f
Note b and c
HEAT/AC SWITCH . . . . . . . . . . . . . 1
Note a and f
Note b and c
HEAT ONLY SWITCH . . . . . . . . . . . 1
Note a and f
Note b and c
PARK BRAKE SWITCH. . . . . . . . . . 1
Note a
Note b
PLASTIC LOAD CHART PLATE . . 10
U-BOLT 1/4”-20 . . . . . . . . . . . . . . . 2
1/4”-20 SERRATED FLNG NUT. . . 8
Ref.
No.
Part
No.
20
21
22
23
L71691
L69546
L69551
L69549
L70116
L69548
L69466
L70501
L69489
L69490
L99844
L99983
L99845
L69824
L69825
24
25
26
27
28
29
30
31
a
Description
Qty.
Req.
WORK PLATFORM SWITCH . . . . . 1
DASH PLASTIC. . . . . . . . . . . . . . . . 1
COLUMN TOP PLASTIC. . . . . . . . . 1
COLUMN BOTTOM PLASTIC. . . . . 1
M6-12X1 SCREW. . . . . . . . . . . . . . 4
COLUMN FACE PLASTIC. . . . . . . . 1
GAUGE MOUNT PLATE . . . . . . . . . 1
REMOVABLE RIVET . . . . . . . . . . . 4
FUEL/HOURMETER GAUGE . . . . . 1
INDICATORS GAUGE. . . . . . . . . . . 1
ROTARY SWITCH, HEAT . . . . . . . . 1
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
CONTROL CABLE 84” . . . . . . . . . . 1
PLASTIC RIVET . . . . . . . . . . . . . . . 2
BINDING SCREW . . . . . . . . . . . . . . 2
b
DL12H SN All
c
When unit is not equipped with this option, use
part # L71088 Switch Hole Plug.
d
Early style dash used 6 hole switch mount plate.
If replacing this older dash, it will also be necessary
to order (2) L71709 switch mount plates.
e
Uses 7 hole switch mount plate # L71709
f
When not equipped with this option, use
part # L69291 Switch Hole Plug.
Usage Table
49
907878/DP0208
DL Series Dynalift
Dash (Later Style)
4
3
2
1
6
7
27
25
29
31
5
6
6
7
17
8
32 26 28
30
11
9
10
6
12
33
34
18
20
22
24
6
35
6
15
14
13
16
17
19
907878/DP0208
21
23
50
PRINTED IN U.S.A.
DL Series Dynalift
Dash (Later Style)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20a
21a
22a
23a
24
25a
26
Part
No.
L69466
L70501
L69489
L69490
101492
101550
L69825
101491
101490
101493
L70017
101524
101494
101528
L70486
L50051
L71709
L71075
L71085
L71082
L71077
L71084
L71083
L71691
L71081
L71086
Description
Qty.
Req.
Ref.
No.
Part
No.
PLATE / GAUGE MOUNT . . . . . . . . 1
RIVET / REMOVABLE . . . . . . . . . . . 4
GAUGE / FUEL-HOURMETER . . . . 1
GAUGE / INDICATORS. . . . . . . . . . 1
PLASTIC / UPPER STEER COL. . . 1
SCREW / 1/4-20x.75" PHILLIPS . . 32
BINDING POST & SCREW . . . . . . . 2
PLASTIC / LOWER STEER COL.. . 1
PLASTIC / DASH. . . . . . . . . . . . . . . 1
PLASTIC / RH CONSOLE. . . . . . . . 1
PLUG / 2.25 " HOLE . . . . . . . . . . . . 1
PLUG / 3.0" HOLE. . . . . . . . . . . . . . 2
PLASTIC / REAR DECK . . . . . . . . . 1
COVER / RECIRC VENT HOLE . . . 1
SCREW /.25-20x1.0 BLK . . . . . . . . 2
NUT / 1/4-20 WHIZ LOCK ZP . . . . . 2
BEZEL / 7 HOLE SWITCH . . . . . . . 2
SWITCH / STEER MODE . . . . . . . . 1
SWITCH / AXLE ALIGNMENT . . . . 1
SWITCH / LIGHTS . . . . . . . . . . . . . 1
SWITCH / HAZARD LIGHTS . . . . . 1
SWITCH / TURN SIGNALS. . . . . . . 1
SWITCH / BEACON . . . . . . . . . . . . 1
SWITCH / WORK PLATFORM . . . . 1
SWITCH / ETHER INJECTION . . . . 1
SWITCH / CLUTCH CUT-OUT . . . . 1
27a
28a
29a
30a
L71076
L71076
L71078
L71080
L71079
L71074
101278
089069
089070
L41848
101378
L99983
31
32b
33
34
35
Description
Qty.
Req.
SWITCH / WIPER-WASHER. . . . . . 1
SWITCH / WIPER-WASHER. . . . . . 1
SWITCH / FAN SPEED . . . . . . . . . . 1
SWITCH / HEATER & A/C. . . . . . . . 1
SWITCH / HEATER ONLY . . . . . . . 1
SWITCH / PARK BRAKE. . . . . . . . . 1
SWITCH / ENGINE FAULT . . . . . . . 1
IGNITION SWITCH . . . . . . . . . . . . . 1
KEY ONLY . . . . . . . . . . . . . . . . . . . 1
START PUSH BUTTON . . . . . . . . . 1
HEATER CONTROL W/CABLE. . . . 1
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
a
When unit is not equipped with this option, use part
number L71088 Switch Hole Plug.
b
When equipped with TIER II engine.
Usage Table
PRINTED IN U.S.A.
51
907878/DP0208
DL Series Dynalift
Heater - A/C Group
(Refer to Usage Table on facing page)
3
9
8
7
5
1
6
2
4
10
20
Med
Yellow
Red
Lo
Orange
Hi
15,16,17
Blue
Blue
32
27
Low
Pressure
Switch
33
19
15,16,17
Cold
Control
15,16
Wire Schematic
40,41,42
43
15,16,17
24
18
21
22
31
23
28
15,16,17
11
25
30
29
12
34
13
14
907878/DP0208
27
13
52
35
26
PRINTED IN U.S.A.
DL Series Dynalift
Heater - A/C Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Part
No.
L500139
L500138
102322
L500137
L500136
L500167
L500166
L500165
L500164
L500168
L500398
103010
L500149
L500145
L500146
L500143
L500579
L500160
L500159
650542
654022
654002
L500151
L500162
L500152
L500150
L500161
L500163
653005
654022
Description
Qty.
Req.
FILTER 12X6X2.19 . . . . . . . . . . . . . 1
1/4”-20X1/2” THUMB SCREW . . . . 2
HOUSING . . . . . . . . . . . . . . . . . . . . 1
COVER . . . . . . . . . . . . . . . . . . . . . . 1
CUT WEATHER SEAL . . . . . . . . . . 1
FASTENER, FRAC-TURN. . . . . . . . 2
RECIRC. COVER . . . . . . . . . . . . . . 1
RECIRC. HOLDER . . . . . . . . . . . . . 1
RECIRC. FILTER. . . . . . . . . . . . . . . 1
KNOB. . . . . . . . . . . . . . . . . . . . . . . . 2
BLOWER ASSEMBLY . . . . . . . . . . . 1
Assembly with one fan motor
FAN MOTOR (one only) . . . . . . . . . 1
Assembly with two fan motors
LEFT FAN MOTOR . . . . . . . . . . . . 1
RIGHT FAN MOTOR . . . . . . . . . . . 1
RESISTOR BLOCK . . . . . . . . . . . . 1
GROMMET, 1-1/4”X7/8” . . . . . . . . . 1
GROMMET 1-3/8”X1” . . . . . . . . . . . 3
GROMMET 7/8”X5/8” . . . . . . . . . . . 1
1/4”-20X1/2” CAP SCREW . . . . . . 11
1/4” LOCK WASHER . . . . . . . . . . . . 9
1/4” FLAT WASHER 1/4 . . . . . . . . . 8
RIGHT. COIL BRACKET . . . . . . . . . 1
HEATER COIL . . . . . . . . . . . . . . . . . 1
LEFT. COIL BRACKET . . . . . . . . . . 1
CUT HEATER HOSE. . . . . . . . . . . . 1
HOSE CLAMP . . . . . . . . . . . . . . . . . 2
WATER VALVE . . . . . . . . . . . . . . . . 1
1/4” NUT . . . . . . . . . . . . . . . . . . . . . 4
1/4” LOCK WASHER . . . . . . . . . . . 4
Ref.
No.
Part
No.
25
26
27
28
29
30
31
32
33
34
35
654002
L500148
L500147
L500578
L500571
L500570
L500573
L500574
L500575
L500576
L500577
L500580
36
37
38
39
40
41
42
43
Description
Qty.
Req.
1/4”FLAT WASHER . . . . . . . . . . . . 4
CUT WEATHERSTRIP SEAL . . . . . 1
CUT TRIM STRIP . . . . . . . . . . . . . . 1
WIRE HARNESS . . . . . . . . . . . . . . 1
MAIN HOUSING WELDMENT . . . . 1
SEMS SCREWS . . . . . . . . . . . . . . . 2
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
COIL MOUNTING CLIP. . . . . . . . . . 1
WIRE ASSEMBLY . . . . . . . . . . . . . . 1
EVAPORATOR COIL. . . . . . . . . . . . 1
COLD CONTROL . . . . . . . . . . . . . . 1
DRAIN FOAM . . . . . . . . . . . . . . . . . 2
--- EXTERNAL COMPONENTS NOT SHOWN --L99843
L99844
ROTARY HEAT CONTROL . . . . . . . 1
(Mounted. on Dash, Incl. Knob)
L99983
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
L99845
CONTROL CABLE 84” . . . . . . . . . . 1
L99847
HEATER HOSE 5/8” . . . . . . . . 16 FT.
L99966
SHUTOFF VALVE . . . . . . . . . . . . . . 1
(Mounted. on Engine)
L500403
EXPANSION VALVE . . . . . . . . . . . . 1
L500664
O-RING #8. . . . . . . . . . . . . . . . . . . . 1
L500665
O-RING #4. . . . . . . . . . . . . . . . . . . . 1
L500666
LOW PRESSURE SWITCH . . . . . . 1
Usage Table
PRINTED IN U.S.A.
53
907878/DP0208
DL Series Dynalift
Heater - A/C Group
13
7,8,9
20
2
23
14
7,8,9
11
7,9
7,8,9
10
28,29,30
31
15
1
24
3
26
27
25
16
7,8,9
17
12
19
21
6
22
18
4
5
33
34
32
35
36
907878/DP0208
54
PRINTED IN U.S.A.
DL Series Dynalift
Heater - A/C Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
Part
No.
L500163
L500162
L500161
L500160
L500159
138563
L500157
L50137
654022
L50051
L500578
101825
L500152
L500151
L500150
L500398
103010
L500148
L500147
L500577
L500576
L500580
Description
Qty.
Req.
VALVE / WATER . . . . . . . . . . . . . . . 1
COIL / HEATER . . . . . . . . . . . . . . . . 1
CLAMP / HOSE . . . . . . . . . . . . . . . . 2
GROMMET / 1-3/8 X 1 . . . . . . . . . . 3
GROMMET / 7/8 X 5/8 . . . . . . . . . . 1
GROMMET / 1-1/4 X 7/8 . . . . . . . . . 1
CAPSCREW, 1/4-20X1/2. . . . . . . . 11
FLAT WASHER, 1/4” . . . . . . . . . . . . 8
LOCK WASHER, 1/4” . . . . . . . . . . 11
NUT / 1/4-20 WHIZ LOCK ZP . . . . . 4
WIRE HARNESS. . . . . . . . . . . . . . . 1
MAIN HOUSING WLDMNT . . . . . . . 1
BRACKET / COIL LH. . . . . . . . . . . . 1
BRACKET / COIL RH . . . . . . . . . . . 1
HOSE / HEATER . . . . . . . . . . . . . . . 1
ASY / BLOWER. . . . . . . . . . . . . . . . 1
STRIP / WEATHERSTRIP. . . . . . . . 1
STRIP / TRIM . . . . . . . . . . . . . . . . . 1
COLD CONTROL, PRE-SET . . . . . 1
EVAPORATOR COIL, 6 ROW. . . . . 1
DRAIN FOAM . . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
22
23
24
25
26
27
28
29
30
31
32
L500570
L500575
L500574
101840
101843
101841
L500403
L500665
L500664
L500666
101650
L50208
L500059
137502
101849
101848
33
34
35
36
00
00
00
00
Description
Qty.
Req.
SEMS SCREW . . . . . . . . . . . . . . . . 2
WIRE ASSEMBLY . . . . . . . . . . . . . . 1
MOUNTING CLIP . . . . . . . . . . . . . . 1
FILTER HOUSING. . . . . . . . . . . . . . 1
FILTER. . . . . . . . . . . . . . . . . . . . . . . 1
HOUSING BULBSEAL . . . . . . . . . . 1
VALVE / EXPANSION . . . . . . . . . . . 1
O-RING #4. . . . . . . . . . . . . . . . . . . . 1
O-RING #8. . . . . . . . . . . . . . . . . . . . 1
LOW PRESSURE SWITCH . . . . . . 1
HEATER DUCT . . . . . . . . . . . . . . . . 1
SCREW / 1/4-20X1/2 . . . . . . . . . . . 3
LOUVER / FIXED VAIN . . . . . . . . . . 1
LOUVER / ROUND 3" . . . . . . . . . . . 2
COVER / RECIRC FILTER . . . . . . . 1
RECIRCULATING FILTER . . . . . . . 1
-- EXTERNAL COMPONENTS NOT SHOWN -101378
L99983
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
101508
DECAL / HEATER CONTROL. . . . . 1
L99847
HEATER HOSE . . . . . . . . . . . . 16 FT.
L99966
SHUTOFF VALVE . . . . . . . . . . . . . . 1
(Mounted on Engine)
Usage Table
PRINTED IN U.S.A.
55
907878/DP0208
DL Series Dynalift
Heater Assembly
3
8
9
1
7
2
5
6
10
4
20
15,16,17
Med
Yellow
Red
Lo
Orange
Hi
Blue
Blue
19
Wire Schematic
27
15,16,17
22
18
24
21
23
28
11
15,16,17
25
29
12
26
13
14
907878/DP0208
56
PRINTED IN U.S.A.
DL Series Dynalift
Heater Assembly
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
Part
No.
L500139
L500138
102322
L500137
L500136
L500167
L500166
L500165
L500164
L500168
L500398
103010
L500149
L500145
L500146
L500143
L500158
L500160
L500159
L50236
654022
L50137
Description
Qty.
Req.
FILTER 12X6X2.19 . . . . . . . . . . . . . 1
1/4”-20X1/2” THUMB SCREW . . . . 2
HOUSING . . . . . . . . . . . . . . . . . . . . 1
COVER . . . . . . . . . . . . . . . . . . . . . . 1
CUT WEATHER SEAL . . . . . . . . . . 1
FASTENER, FRAC-TURN. . . . . . . . 2
RECIRC. COVER . . . . . . . . . . . . . . 1
RECIRC. HOLDER . . . . . . . . . . . . . 1
RECIRC. FILTER. . . . . . . . . . . . . . . 1
KNOB. . . . . . . . . . . . . . . . . . . . . . . . 2
BLOWER ASSEMBLY . . . . . . . . . . . 1
Assembly with one fan motor
Assembly with two fan motors
LEFT FAN MOTOR . . . . . . . . . . . . 1
RIGHT FAN MOTOR . . . . . . . . . . . 1
RESISTOR BLOCK . . . . . . . . . . . . 1
PLASTIC PLUG, 1 3/8” . . . . . . . . . . 2
GROMMET 1-3/8”X1” . . . . . . . . . . . 2
GROMMET 7/8”X5/8” . . . . . . . . . . . 1
1/4”-20X1/2” BOLT. . . . . . . . . . . . . 11
LOCK WASHER 1/4 . . . . . . . . . . . . 9
FLAT WASHER 1/4 . . . . . . . . . . . . . 8
Ref.
No.
Part
No.
18
19
20
21
22
23
24
L500151
L500162
L500152
L500150
L500161
L500163
L50051
654022
L50137
L500148
L500147
L500578
L500571
L500573
25
26
27
28
29
30
31
32
33
Description
Qty.
Req.
RIGHT. COIL BRACKET . . . . . . . . . 1
HEATER COIL . . . . . . . . . . . . . . . . . 1
LEFT. COIL BRACKET . . . . . . . . . . 1
CUT HEATER HOSE. . . . . . . . . . . . 1
HOSE CLAMP . . . . . . . . . . . . . . . . . 2
WATER VALVE . . . . . . . . . . . . . . . . 1
HEX NUT 1/4. . . . . . . . . . . . . . . . . . 4
1/4” LOCK WASHER . . . . . . . . . . . 4
1/4” FLAT WASHER . . . . . . . . . . . . 4
CUT WEATHERSTRIP SEAL . . . . . 1
CUT TRIM STRIP . . . . . . . . . . . . . . 1
WIRE HARNESS . . . . . . . . . . . . . . 1
MAIN HOUSING WELDMENT . . . . 1
BULB SEAL . . . . . . . . . . . . . . . . . . . 1
--- EXTERNAL COMPONENTS NOT SHOWN --L99843
L99844
ROTARY HEAT CONTROL . . . . . . . 1
(Mounted. on Dash, Incl. Knob)
L99983
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
L99845
CONTROL CABLE 84” . . . . . . . . . . 1
L99847
HEATER HOSE 5/8” X 16’ . . . . . . . 1
L99966
SHUTOFF VALVE . . . . . . . . . . . . . . 1
(Mounted. on Engine)
Usage Table
PRINTED IN U.S.A.
57
907878/DP0208
DL Series Dynalift
Heater Assembly
13
7,8,9
2
14
7,8,9
11
7,8,9
10
1
15
3
21
19
20
7,8,9
16
17
12
6
18
4
5
23
24
22
25
26
907878/DP0208
58
PRINTED IN U.S.A.
DL Series Dynalift
Heater Assembly
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
Part
No.
L500163
L500162
L500161
L500160
L500159
L500158
L500157
L50137
654022
L50051
L500578
101825
L500152
L500151
L500150
L500398
103010
L500148
L500147
Description
Qty.
Req.
VALVE / WATER . . . . . . . . . . . . . . . 1
COIL / HEATER . . . . . . . . . . . . . . . . 1
CLAMP / HOSE . . . . . . . . . . . . . . . . 2
GROMMET / 1-3/8 X 1 . . . . . . . . . . 2
GROMMET / 7/8 X 5/8 . . . . . . . . . . 1
PLUG / PLASTIC / 1-3/8 . . . . . . . . . 2
CAPSCREW, 1/4-20X1/2. . . . . . . . 11
FLAT WASHER, 1/4” . . . . . . . . . . . . 8
LOCK WASHER, 1/4” . . . . . . . . . . 11
NUT / 1/4-20 WHIZ LOCK ZP . . . . . 4
WIRE HARNESS. . . . . . . . . . . . . . . 1
MAIN HOUSING WLDMNT . . . . . . . 1
BRACKET / COIL LH. . . . . . . . . . . . 1
BRACKET / COIL RH . . . . . . . . . . . 1
HOSE / HEATER . . . . . . . . . . . . . . . 1
ASY / BLOWER. . . . . . . . . . . . . . . . 1
STRIP / WEATHERSTRIP. . . . . . . . 1
STRIP / TRIM . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
19
20
21
22
101840
101843
101841
101650
L50208
L500059
137502
101849
101848
23
24
25
26
27
28
29
30
Description
Qty.
Req.
FILTER HOUSING. . . . . . . . . . . . . . 1
FILTER. . . . . . . . . . . . . . . . . . . . . . . 1
HOUSING BULBSEAL . . . . . . . . . . 1
HEATER DUCT . . . . . . . . . . . . . . . . 1
SCREW / 1/4-20X1/2 . . . . . . . . . . . 3
LOUVER / FIXED VAIN . . . . . . . . . . 1
LOUVER / ROUND 3" . . . . . . . . . . . 2
COVER / RECIRC FILTER . . . . . . . 1
RECIRCULATING FILTER . . . . . . . 1
--EXTERNAL COMPONENTS NOT SHOWN-101378
L99983
KNOB ONLY. . . . . . . . . . . . . . . . . . 1
101508
DECAL / HEATER CONTROL. . . . . 1
L99847
HEATER HOSE . . . . . . . . . . . . 16 FT.
L99966
SHUTOFF VALVE . . . . . . . . . . . . . . 1
(Mounted on Engine)
Usage Table
PRINTED IN U.S.A.
59
907878/DP0208
DL Series Dynalift
A/C Condenser Group - Early Model
2
4
3
5
TRANSMISSION
OIL COOLER
6
1
4
6
6
REAR
Ref.
No.
01
02
03
04
05
06
Part
No.
L50841
L70391
L71357
L50051
L70396
L50211
907878/DP0208
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
--- FOR SERIAL NUMBER ---
1/4”-20X2” BOLT . . . . . . . . . . . . . . . 4
CONDENSER COIL . . . . . . . . . . . . 1
CONDENSER SPACER . . . . . . . . . 4
1/4”-20 WHIZ LOCK NUT . . . . . . . . 8
CONDENSER MOUNT . . . . . . . . . . 2
1/4”-20X3/4” BOLT . . . . . . . . . . . . . 4
60
PRINTED IN U.S.A.
DL Series Dynalift
A/C Condenser Group - Later Model
8
4
11
2
9
3
1
10
5,6,7
12
L71674 Shown
Ref.
No.
00
01
02
03
04
05
06
07
08
09
10
Part
No.
L71520
L500591
L500592
L500593
L500594
L50236
L50137
654022
L50051
L500595
L500596
PRINTED IN U.S.A.
Description
Qty.
Req.
CONDENSER BASE PLATE. . . . . . 1
CONDENSER TOP PLATE . . . . . . . 1
CONDENSER COIL PLATE . . . . . . 1
CONDENSER FAN ASSEMBLY . . . 2
1/4”-20X1/2” CAP SCREW . . . . . . 12
FLAT WASHER 1/4” . . . . . . . . . . . 12
LOCK WASHER 1/4” . . . . . . . . . . . . 1
1/4”-20 SERRATED FLANGE NUT . 8
CONDENSER COIL . . . . . . . . . . . . 1
SHEET METAL SCREW . . . . . . . . . 6
Ref.
No.
Part
No.
11
L71720
L70075
12
100091
L71674
100501
101668
61
Description
Qty.
Req.
CONDENSER WIRE HARNESS. . . 1
RELAY (not shown) . . . . . . . . . . . . 1
CONDENSER MOUNT . . . . . . . . . . 1
3-section high boom
3-section low boom
4-section high boom
4-section low boom
907878/DP0208
DL Series Dynalift
A/C Group - Hoses, Compressor, and Dryer
22
Drier
21
20
19
HOSES
8
25
7
Early Style
10
24
23
Later Style
15
9
13
28
18
13
8
27
10
26
10
16
12
15
11
8
14
17
907878/DP0208
62
PRINTED IN U.S.A.
DL Series Dynalift
A/C Group - Hoses, Compressor, and Dryer
Ref.
No.
Part
No.
01
L71352
L71715
02
03
04
05bf
L71353
L71716
L70798
L70799
L71717
101687
L71754
06bf
07
08
09
10
11
12c
13
14d
15
16
17
18
19
20
21
22
23
24g
25
26h
27h
28h
L71718
101688
L71755
L70677
L50061
L70722
L50261
L520005
101226
L50836
100751
L52026
L70778
Note e
L50147
L70696
L50228
L50056
L70723
L50228
L50056
L500720
L71721
L68569
102171
L70817
L70786
102169
102170
102168
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
HOSE ASSEMBLY . . . . . . . . . . . . . 1
Note a (13/32”X 107”)
Note b (13/32” X 150”)
HOSE ASSEMBLY . . . . . . . . . . . . . 1
Note a (5/16” X 44”) . . . . . . . . . . . . 1
Note b (5/16” X 102”). . . . . . . . . . . . 1
HOSE ASY, 5/16” X 72”. . . . . . . . . . 1
HOSE ASY, 1/2” X 122”. . . . . . . . . . 1
HOSE ASSEMBLY . . . . . . . . . . . . . 1
(3-section low boom) 13/32” X 96”
(4-section low boom) 13/32” X 100” .
(High boom)13/32” X 66”
HOSE ASSEMBLY . . . . . . . . . . . . . 1
(High boom) 5/16” X 66”
ADJUSTER . . . . . . . . . . . . . . . . . . . 1
3/8-16 SER.FLANGE NUT . . . . . . . 6
AC COMPRESSOR. . . . . . . . . . . . . 1
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 3
3/8-16 NYLON INSERT NUT . . . . . 2
AC COMPRESSOR BRACKET. . . . 1
3/8-16X1 3/4” BOLT. . . . . . . . . . . . . 1
ENGINE MOUNT. . . . . . . . . . . . . . . 1
3/8-16X1 1/4” BOLT. . . . . . . . . . . . . 4
BELT - AC COMPRESSOR. . . . . . . 1
ENGINE MOUNT/ AC BRACKET
WASHER, 3/8 SPRING LOCK . . . . 4
DRYER MOUNT BRACKET . . . . . . 1
5/16”-18X1/2” CAP SCREW. . . . . . 4
5/16”-18 NUT . . . . . . . . . . . . . . . . . 2
A/C DRYER . . . . . . . . . . . . . . . . . . . 1
5/16”-18X1/2” CAP SCREW. . . . . . 2
5/16”-18 FLANGE NUT . . . . . . . . . 2
BINARY SWITCH . . . . . . . . . . . . . . 1
A/C WIRE HARNESS . . . . . . . . . . . 1
V-BELT PULLEY . . . . . . . . . . . . . . . 1
Note g
Note h
PULLEY ADAPTER . . . . . . . . . . . . . 1
BELT GUARD . . . . . . . . . . . . . . . . . 1
CRANKSHAFT PULLEY . . . . . . . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 1
CRANKSHAFT PULLEY BOLT . . . . 1
a
63
Part
No.
Description
Qty.
Req.
--- FOR SERIAL NUMBER --DL6H Thru SN 20423
DL6L Thru SN 25440
DL8H Thru SN 30407
DL8L Thru SN 35368
DL10H Thru SN 40189
DL10L Thru SN 45118
DL12H Thru SN 50122
b
c
This AC Compressor bracket replaces the bracket
shown in reference 17. This bracket must be used
with engine mount PN 100751 (ref. 14)
d
This engine mount replaces the engine mount
shown in reference 17. When unit is equipped
with air conditioning, this mount must be used
with AC Compressor bracket PN 100226 (ref. 12)
e
The engine mount and AC Comp. bracket shown
are replaced by items 12 and 14.
f
Items 5 and 6 are not used on units listed under
note “a”.
g
h
907878/DP0208
DL Series Dynalift
Steering Column Group
1
3
2
FRONT
4
5
6
23
18
22
21
7
8
10
18
9
20
LS
11
19
L
T
12
R
P
13
17
16
15
14
907878/DP0208
64
PRINTED IN U.S.A.
DL Series Dynalift
Steering Column Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
Part
No.
Description
L69596
L41261
L69595
L70120
P054800
L50051
L52026
L51591
L445013
L69925
L69935
L69936
L69933
L69934
L446024
L64524
18
L69128
101881
L69012
19
L99425
L500080
Qty.
Req.
HORN BUTTON W/TRUMPET . . . . 1
COLUMN NUT. . . . . . . . . . . . . . . . . 1
STEERING WHEEL . . . . . . . . . . . . 1
STEERING COLUMN . . . . . . . . . . . 1
MUFFLER CLAMP BRACKET . . . . 1
1/4-20 FLANGE NUT. . . . . . . . . . . . 2
3/8-16X1-1/4” BUTTN HD BOLT . . . 4
ADAP -4ORM -4JICM . . . . . . . . . . . 1
ADAP -8ORM -8JICM 45 ELBOW . 3
HOSE -4 A4/A6 100” . . . . . . . . . . . 1
HOSE -6 A8/A6 108” . . . . . . . . . . . . 1
HOSE -6 A8/DS6 100”. . . . . . . . . . . 1
HOSE -6 A8/A6 60” . . . . . . . . . . . . . 1
HOSE -6 A8/DS8 88”. . . . . . . . . . . . 1
ADAP -8JICFS -8JICM SWVL. . . . . 1
CHECK VALVE . . . . . . . . . . . . . . . . 1
STEER MOTOR ASY. . . . . . . . . . . . 1
Note a
Note b
F-N-R/1-2-3-4 SHIFTER. . . . . . . . . 1
(includes item #23)
BOOT, SHIFTER . . . . . . . . . . . . . . 1
STEER COL. MT. BRACKET . . . . . 1
Ref.
No.
Part
No.
Description
20
21
22
23
L50452
L50101
L500439
105236
a
b
Qty.
Req.
1/4-20X2-1/4” BOLT . . . . . . . . . . . . 2
M5-.8X35 MM SHCS . . . . . . . . . . . . 2
DECAL, SHIFTER 1-2-3-4. . . . . . . . 1
SHIFTER CLAMP (only) . . . . . . . . . 1
(included with item #18)
Hose Locator
Ref
No.
From Port
10
11
12
13
14
STEER
STEER
STEER
STEER
STEER
PRINTED IN U.S.A.
MOTOR
MOTOR
MOTOR
MOTOR
MOTOR
To Port
“LS” (IN CAB)
“L” (IN CAB)
“R” (IN CAB)
“T” (IN CAB)
“P” (IN CAB)
LEVEL VALVE “LSB”
STEER SELECT VALVE “P’
STEER/BRAKE MANIFOLD (TOP RIGHT SIDE)
HYDRAULIC TANK RETURN MANIFOLD
HYDRAULIC PUMP
(Refer to item #32 hydraulic pump page)
65
907878/DP0208
DL Series Dynalift
Console Tilt Group
12
11
5
21
24
15
22
14
23
4
2
13
16
17
5
1
20
9
3
19
18
7
6
10
907878/DP0208
25
8
66
PRINTED IN U.S.A.
DL Series Dynalift
Console Tilt Group
Ref.
No.
01
02
03
04
05
06
07
08a
09
10
11
12
13
Part
No.
101884
L69542
L50367
L69085
L69095
L69100
L69079
L69081
L69162
L510046
L50051
L69238
L510046
L500023
PRINTED IN U.S.A.
Description
Qty.
Req.
MOUNT WELDMENT . . . . . . . . . . . 1
STEERING MOUNT WELD. . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . 4
DOWEL . . . . . . . . . . . . . . . . . . . . . . 2
COMPRESSION SPRING. . . . . . . . 1
CATCH PIN WELD. . . . . . . . . . . . . . 1
SPACER 3/16” . . . . . . . . . . . . . . . . . 1
SPACER 1/16” . . . . . . . . . . . . . . . . . 1
CATCH PLATE . . . . . . . . . . . . . . . . 1
1/4”-20X1-1/4” BOLT . . . . . . . . . . . . 3
1/4”-20 SERR. FLANGE NUT . . . . . 3
TILT LEVER WELD. . . . . . . . . . . . . 1
1/4”-20X1-1/4”” BOLT . . . . . . . . . . . 1
1/4”-20 NYLON INSERT NUT . . . . . 1
67
Ref.
No.
Part
No.
Description
Qty.
Req.
14
15
16
17
18
19
20
21
22
23
24
25
L69226
L69099
L69232
L69101
L69155
L50364
L50139
L69392
L69355
L50137
L50145
L500081
a
Replaces two plates used on earlier units.
TILT LEVER CABLE . . . . . . . . . . . . 1
PUSH-ON RETAINER . . . . . . . . . . . 1
TILT HANDLE KNOB. . . . . . . . . . . . 1
PIVOT PIN . . . . . . . . . . . . . . . . . . . . 1
PIN GUIDE . . . . . . . . . . . . . . . . . . . 1
1/4”-20X1-1/2” BOLT . . . . . . . . . . . . 2
1/4” LOCK WASHER . . . . . . . . . . . . 2
WAVE SPRING . . . . . . . . . . . . . . . . 1
NYLON SHOULDER WASHER . . . 1
1/4” WASHER . . . . . . . . . . . . . . . . . 1
3/8” WASHER . . . . . . . . . . . . . . . . . 1
BRACKET, LOWER PLASTIC. . . . . 1
907878/DP0208
DL Series Dynalift
Brake Pedal Group
2
8
3
7
1
5
6
9
T
4
P
10
B
11
13
12
10
14
16
15
20
16
19
17
18
907878/DP0208
68
PRINTED IN U.S.A.
DL Series Dynalift
Brake Pedal Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
Description
L70184
L50607
L42342
L70183
L50066
L520004
L69927
L69926
L444002
L445003
Qty.
Req.
LINK. . . . . . . . . . . . . . . . . . . . . . . . . 2
COTTER PIN 1/8X1 . . . . . . . . . . . . 2
CLEVIS PIN 3/8X1-1/4 . . . . . . . . . . 2
ROD END 3/8”. . . . . . . . . . . . . . . . . 1
3/8-24 NUT . . . . . . . . . . . . . . . . . . . 1
5/16-18 NYLON INSERT NUT . . . . 2
HOSE -4 A6/A6 81” . . . . . . . . . . . . . 1
HOSE -4 A6/DS6 100”. . . . . . . . . . . 1
ADAP -6ORM -6JICM STR . . . . . . . 1
ADAP -6ORM -6JICM 90 DEG . . . . 2
Ref.
No.
Part
No.
11
12
13
14
15
16
17
18
19
20
L50823
L69572
L69929
L69590
L69789
L64890
L50217
L70248
L70250
L70435
Description
Qty.
Req.
5/16-18x1” BOLT . . . . . . . . . . . . . . . 2
BRAKE MODULATING VALVE . . . . 1
HOSE -4 A6/A4 102” . . . . . . . . . . . . 1
BRAKE LEVER WELD. . . . . . . . . . 1
RUBBER PAD . . . . . . . . . . . . . . . . . 1
ELECTRIC SWITCH . . . . . . . . . . . . 1
CS 1/4-20X3-1/2 . . . . . . . . . . . . . . . 4
CLAMP BLOCK AND PLATE . . . . . 2
CLAMP SPACER. . . . . . . . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
07
08
13
BRAKE MODULATING VALVE “T”
BRAKE MODULATING VALVE “P”
BRAKE MODULATING VALVE “B”
SAHR VALVE “AO”
BRAKE MANIFOLD (BOTTOM PORT)
PRINTED IN U.S.A.
69
907878/DP0208
DL Series Dynalift
Throttle Pedal Group
10
11
2
9
1
3
12
8
9
Manual Throttle
7
6
5
4
13
Electronic Throttle
907878/DP0208
70
PRINTED IN U.S.A.
DL Series Dynalift
Throttle Pedal Group
Ref.
No.
Part
No.
01a
L70568
L50230
L50143
L50056
L69619
L50823
L50143
L70565
L69615
L50403
L50145
L520005
L69392
L69789
L69607
L580009
L50050
L70435
L50565
L43965
L69634
02a
03a
04a
05a
06a
07a
08a
09a
10a
11a
12a
13
101291
105502
L50143
L50823
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
CABLE MOUNT W/BUSHING. . . . . 1
5/16”-18X3/4” CARRIAGE BOLT . . 2
5/16” LOCK WASHER . . . . . . . . . . 2
5/16”-18 SERR. FLANGE NUT . . . 2
OUTER MOUNT W/BUSHING . . . . 1
5/16”-18X1” BOLT . . . . . . . . . . . . . 2
5/16” LOCK WASHER . . . . . . . . . . 2
THROTTLE LEVER WELD. . . . . . . 1
THROTTLE PEDAL WELD. . . . . . . 1
3/8”-16X1-1/4” BOLT . . . . . . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . . 1
3/8”-16 CENTER LOCK NUT . . . . . 1
WAVE SPRING . . . . . . . . . . . . . . . . 1
RUBBER PAD . . . . . . . . . . . . . . . . . 1
THROTTLE CABLE. . . . . . . . . . . . . 1
BALL JOINT #10-32 . . . . . . . . . . . . 1
#10-32 NUT . . . . . . . . . . . . . . . . . . 1
BEARING. . . . . . . . . . . . . . . . . . . . . 2
5/16”-18X6” CARRIAGE BOLT . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 1
THROTTLE SPRING. . . . . . . . . . . . 1
FOOTPEDAL, ELECTRONIC . . . . . 1
Note b
Note c
5/16” LOCK WASHER . . . . . . . . . . 2
5/16”-18X1” BOLT . . . . . . . . . . . . . 2
71
Part
No.
Description
Qty.
Req.
a
When equipped with engines prior to TIER II.
b
When equipped with TIER II engine.
DL6H SN 20824 Thru 20924
DL6L SN 25616 Thru 25647
DL8H SN 30852 Thru 31006
DL8L SN 35504 Thru 35545
DL10H SN 40499 Thru 40905
DL10L SN 45185 Thru 45393
DL12H SN 50221 Thru 50489
c
When equipped with TIER II or higher engine.
907878/DP0208
DL Series Dynalift
Seat Group and Right Hand Dash
23
24
22
25
1
21
20
2
19
3
3
6
4
6
8
4
3
4
5
5
4
6
3
6
4
5
5
9
4
7
7
10
6
5
16
11
12
17
18
9
10
Option
Standard
15
13
14
907878/DP0208
72
PRINTED IN U.S.A.
DL Series Dynalift
Seat Group and Right Hand Dash
Ref.
No.
Part
No.
01
100135
02
L99454
03
04
05
06
07
08
09
10
11c
12i
L70634
L510041
L50517
L50196
L70212
L50141
L50141
L50056
L70592
L68496
13d
14d
L70449
L70450
L50051
L70453
L70201
15d
16j
17
18
19
Description
L70452
100071
L50823
20f
L69279
L71072
21
L500247
L71071
22f
25
00
L69280
L71073
L70015
L69756
L50202
L69755
L50483
L64078
Ref.
No.
SEAT . . . . . . . . . . . . . . . . . . . . . . . . 1
(Includes item 2 - Arm Rest)
SEAT ARM REST (Left Hand) . . . . . 1
(Included with item 1 - Seat)
SEAT BELT (Incls. tether straps). . . 1
7/16”-20X1” BOLT . . . . . . . . . . . . AR
7/16”-20 NYLON INSERT NUT . . AR
7/16” FLAT WASHER . . . . . . . . . . AR
TETHER BRACKET . . . . . . . . . . . . 2
5/16” WASHER (spacers). . . . . . . AR
5/16” WASHER . . . . . . . . . . . . . . . . 4
5/16”-18 SERR. FLANGE NUT . . . . 4
SEAT EXTENSION . . . . . . . . . . . . . 1
SUSPENSION BELLOWS (option) . 1
(includes seat belt bracket as shown)
MANUAL TUBE BRACKET . . . . . . . 1
TUBE U-BOLTS 1/4”-20 . . . . . . . . . 2
1/4”-20 WHIZ LOCK NUTS . . . . . . 4
MANUAL TUBE . . . . . . . . . . . . . . . . 1
SEAT BELT MOUNT (Standard) . . . 1
SEAT RISER (Standard Seat) . . . . . 1
Note d
Note e
5/16”-18X1” BOLT . . . . . . . . . . . . . . 4
RIGHT HAND CONSOLE . . . . . . . . 1
Note a
Note g
Note h
SWITCH OUTRIGGER (Left) . . . . . 1
Note a
Note b
LEVEL SWITCH . . . . . . . . . . . . . . . 1
Note a
Note b
SWITCH OUTRIGGER (Right) . . . . 1
Note a
Note b
ARM REST MOUNT BRKT. . . . . . . 1
ARM REST . . . . . . . . . . . . . . . . . . . 1
1/4”-20X5/8” BUTTON HD BOLT . . 2
KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1
3/8”-16X1” CARRIAGE BOLT . . . . 1
L69545
L71147
101493
24
23
Qty.
Req.
a
73
Description
Qty.
Req.
--- SERIAL NUMBERS --DL6H SN 20286 and before , except 20272 and
20273
DL6L SN 25332 and before, except 25327, 25328,
25330 and 25331
DL8H SN 30292 and before, except 30289
DL8L SN 35288 and before, except 35280 and
35281
b
DL6H SN 20272, 20273, 20287 and up
DL6L SN 25327, 25328, 25330, 25331,
25333 and up
DL8H SN 30289, 30293 and up
DL8L SN 35280, 35281, 35289 and up
DL12H SN All
c
Used only with low boom units.
d
Units that use the manual tube (item 15).
Early models without the pouch behind the seat
used a container to hold the operator’s manual.
e
Units that have a seats with a pouch for operator’s
manual.
f
When not equipped with outriggers, use
L71088 Switch hole plug in place of switches.
g
h
i
Suspension seat option
j
Standard seat.
-- ITEMS NOT SHOWN -DUAL RATE ALARM (Buzzer). . . . . 1
PRINTED IN U.S.A.
Part
No.
907878/DP0208
Personnel Work Platform System
DL Series Dynalift
Personnel Work Platform - Cab Group
Level Sensor
located to the
rear of the right console
1
3
4
2
5
6
PWP Control Module
located under front dash
above brake pedal.
7
907878/DP0208
74
PRINTED IN U.S.A.
DL Series Dynalift
Personnel Work Platform - Cab Group
Ref.
No.
01
02a
03
04a
05a
06
07b
Part
No.
L71691
L71564
L71553
L50486
L50051
104078
104065
101689
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
WORK PLATFORM SWITCH . . . . . 1
LEVEL SWITCH BRACKET . . . . . . 1
LEVEL SENSOR . . . . . . . . . . . . . . . 1
1/4”-20X5/8” HEX HEAD BOLT . . . . 8
1/4”-20 FLANGE NUT . . . . . . . . . . . 8
CONTROL MODULE. . . . . . . . . . . . 1
WIRE HARNESS. . . . . . . . . . . . . . . 1
(used with 104078 module)
(used with L71710 module)
75
Part
No.
Description
Qty.
Req.
a
Used only on the following units:
DL6L; SN 25587 and before
DL6H; SN 20797 and before
b
Refer to the control module which has a
part number label affixed to it.
907878/DP0208
DL Series Dynalift
Personnel Work Platform - 3 Section Boom
Three-Section
BOOM MODELS
2
1
3
(Attached to Personnel
Work Platform)
4
Pressure Switch
Refer to brake manifold in
hydraulic section.
110 “
6
5
612”
Ref.
No.
Part
No.
00a
L71729
01
02
03
102408
L71726
L71725
907878/DP0208
Description
Qty.
Req.
REMOTE SWITCH W/CABLE. . . . . 1
(Includes items 1-3)
CABLE ASSEMBLY . . . . . . . . . . . . . 1
REMOTE STOP SWITCH . . . . . . . . 1
REMOTE SWITCH ENCLOSURE. . 1
76
Ref.
No.
Part
No.
04
05
L71750
L71732
06
L70415
Description
Qty.
Req.
REMOTE SWITCH POUCH . . . . . . 1
REMOTE SWITCH HARNESS . . . . 1
(Consists of two cables)
PRESSURE SWITCH . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Personnel Work Platform - 4 Section Boom
55’ BOOM
MODELS
1
3
(Attached to Personnel
Work Platform)
(Located in area
under engine cover)
2
4
Late Model
Early Model
7
6
5
Pressure Switch
Refer to brake manifold in
hydraulic section.
Ref.
No.
01a
02ac
03b
04bc
05
06d
07d
00
Part
No.
Description
Chain and Shackle
Used to secure
Personnel Work Platform
on both three-section and foursection booms
Qty.
Req.
Ref.
No.
102676
102675
WIRELESS SWITCH POUCH. . . . . 1
RADIO REMOTE SYSTEM . . . . . . . 1
(Transmitter and Receiver)
101198
WIRELESS SWITCH POUCH. . . . . 1
102677
RADIO REMOTE SYSTEM(kit) . . . . 1
(Transmitter and Receiver)
L70415
PRESSURE SWITCH . . . . . . . . . . . 1
L71752
5/16” CHAIN SHACKLE . . . . . . . . . 1
L71751
5/16” CHAIN GR40 16 LINKS . . . . 1
-- ITEMS NOT SHOWN -RADIO REMOTE HARNESS . . . . . 1
(e-stop receiver)
102655
Note c
101199
Note d
PRINTED IN U.S.A.
77
Part
No.
Description
Qty.
Req.
a
b
c
The transmitter and receiver are frequency
matched, therefore, it is required to purchase
both as a set.
d
Chain shackle and chain are used on both four
and Three-Section boom applications to secure the
Personnel Work Platform.
907878/DP0208
DL Series Dynalift
Radio Remote - Transmitter and Receiver
1
3
2
7
4
5
6
TO PWP/WPS HARNESS
AND TO RADIO REMOTE
MANIFOLD AT REAR OF
MACHINE
907878/DP0208
78
PRINTED IN U.S.A.
DL Series Dynalift
Radio Remote -Transmitter and Receiver
Ref.
No.
00
01a
02
03
04
05
06
07
Part
No.
103414
103479
103482
NSS
NSS
103475
103476
104675
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE, RADIO REMOTE . . . . 1
(Includes all items shown)
REMOTE TRANSMITTER. . . . . . . . 1
SWITCH, TOGGLE 3 POS. MIL . . . 4
REMOTE RECEIVER . . . . . . . . . . . 1
ENCLOSURE / CIRCUIT BOARD. . 1
LANYARD (wire cable) . . . . . . . . . . 1
SNAP RING, LANYARD . . . . . . . . . 1
LABEL . . . . . . . . . . . . . . . . . . . . . . . 1
79
Ref.
No.
Part
No.
Description
Qty.
Req.
00
104963
a
Requires programming; refer to “Radio Remote
Operators manual “ that was included with the
Radio Remote Control at the time of purchase.
-- ITEMS NOT SHOWN -WIRE HARNESS. . . . . . . . . . . . . . . 1
(to existing PWP wire harness)
907878/DP0208
Chassis
DL Series Dynalift
Rear Access Door Group
1
2
3
4
5
1
6
7
23
6
21
24
22
20
8
25
12
9
26
10
6
11
19
12
11
7
14
15
16
17
18
17
11
12
13
907878/DP0208
80
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Rear Access Door Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
Part
No.
L50141
L70326
L50607
L70225
L99157
L70257
L50059
L70226
L70227
L500657
L71305
L520019
L50151
L50292
L70200
L50230
L50056
L70701
L500339
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
18
5/16” FLAT WASHER . . . . . . . . . . . 2
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1
1/8X1” COTTER PIN . . . . . . . . . . . . 2
CAMLOCK . . . . . . . . . . . . . . . . . . . . 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
LATCH ASY. HANDLE . . . . . . . . . . . 1
5/16-24 NUT . . . . . . . . . . . . . . . . . . 4
5/16-24 BALL JOINT . . . . . . . . . . . . 2
LINKAGE ROD . . . . . . . . . . . . . . . . 1
REAR DOOR . . . . . . . . . . . . . . . . . 1
PLUG, REAR HOOD . . . . . . . . . . . . 1
1/2” FLAT WASHER . . . . . . . . . . . . 3
1/2-13x3” BOLT . . . . . . . . . . . . . . . . 1
BACKUP ALARM. . . . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 2
5/16-18 FLARE NUT . . . . . . . . . . . . 2
TAIL LIGHT W CONNECTOR . . . . . 2
RUBBER MOUNTING BEZEL . . . . 2
Qty.
Req.
BACKUP LIGHT . . . . . . . . . . . . . . . 1
Note a (early models)
Note b (later models)
RUBBER MOUNTING BEZEL . . . . 1
JUMPER - BACKUP LIGHT . . . . . . 1
LATCH . . . . . . . . . . . . . . . . . . . . . . . 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
1/2-13X1-1/2” CARRIAGE. BOLT . . 2
LATCH MOUNT . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . . 1
LATCH ROD ASY . . . . . . . . . . . . . . 1
20
21
22
23
24
25
26
L70041
L71595
L500606
100102
L70216
L99157
L50603
L69766
131940
L50145
L520005
131799
L70009
00
L60587
a
Use this backup light if the center opening in rear
door is the same size as the tail light openings.
b
Use this backup light if the center opening in the
rear door is smaller than the tail light openings.
19
81
Description
-- ITEMS NOT SHOW -SINGLE DIODE . . . . . . . . . . . . . . AR
(located in the wire harness near tail
lights)
907878/DP0208
Chassis
DL Series Dynalift
Engine -Transmission Cover Group
1
2
Early style front
panel shown.
3
4
5
6
7
8
4
35
34
33
9
32
15
31
30
34
4
10
29
7
37
45
11
12
27 33 28
38
46
36
47
26
45
41
46
44
39
43
25
40
4
23
42
6
24
13
14
15
22
19
15
21
6
20
907878/DP0208
18
17 13
82
16
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Engine -Transmission Cover Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10c
11c
12c
13
14c
15
16c
17c
18c
19
20
21
22
23c
24c
25
26
27
28bd
29b
30b
31
32
33
34
35
36d
37d
38d
39d
Part
No.
L70239
L70198
L99157
L69465
L50056
L70045
L50230
L50461
101349
L71168
101488
L70321
L70065
L70067
L99157
L520005
L70586
L50145
L70197
L70588
L70162
L50050
L580009
L50211
L50051
L70322
L70064
L71172
102002
101967
L71337
L70619
L68133
L68134
L68135
L71336
L50251
L71193
L69488
L50056
L69473
L69468
101421
650835
654022
101422
L99157
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
TRANSMISSION COVER . . . . . . . . 1
LATCH - TRANSMISSION COVER. 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
HINGE . . . . . . . . . . . . . . . . . . . . . . . 7
5/16-18 FLARE NUT . . . . . . . . . . . 18
HORN . . . . . . . . . . . . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 7
5/16-18X1” CARRIAGE BOLT. . . . . 5
END PANEL - FRONT. . . . . . . . . . . 1
Note a (not shown)
Note b (shown)
ENGINE COVER HOOD . . . . . . . . . 1
FRONT LATCH MOUNT . . . . . . . . . 1
ROTARY LATCH (LEFT) . . . . . . . . . 1
PADDLE HANDLE . . . . . . . . . . . . . . 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
STRIKER MOUNT (FRONT) . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . 10
STRIKER PIN . . . . . . . . . . . . . . . . . 2
STRIKER MOUNT (REAR) . . . . . . . 1
LINKAGE ROD . . . . . . . . . . . . . . . . 2
10-32 NUT . . . . . . . . . . . . . . . . . . . . 4
BALL JOINT 10-32 ROD END. . . . . 4
1/4-20X3/4” BOLT . . . . . . . . . . . . . . 4
1/4-20 FLARE NUT . . . . . . . . . . . . . 4
REAR LATCH MOUNT . . . . . . . . . . 1
ROTARY LATCH (RIGHT). . . . . . . . 1
ETHER MOUNT BRACKET . . . . . . 1
END PANEL WELDMENT . . . . . . . . 1
BAFFLE, AIR RECIRC. . . . . . . . . . . 1
Note a and f (not shown)
Note b and e (shown)
BULB SEAL, ENGINE COVER . . . . 1
CAPTIVE SCREW. . . . . . . . . . . . . . 2
SCREW RETAINER . . . . . . . . . . . . 2
SCREW RECEPTACLE . . . . . . . . . 2
BAFFLE, TOP PLATE . . . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 6
ENGINE COVER MOUNT. . . . . . . . 1
BALL STUD . . . . . . . . . . . . . . . . . . . 6
5/16-18 FLARE NUT . . . . . . . . . . . 6
GAS SPRING . . . . . . . . . . . . . . . . . 3
(Does not include item 33)
RUBBER BUMPER . . . . . . . . . . . . . 2
LATCH . . . . . . . . . . . . . . . . . . . . . . . 1
CS 1/4x1 C5ZY . . . . . . . . . . . . . . . . 4
LW 1/4 RZY . . . . . . . . . . . . . . . . . . . 4
HANDLE-PADDLE, W/KEY . . . . . . . 1
KEY ONLY (CH751) . . . . . . . . . . . . 1
40d
41d
42d
43d
44d
45d
46d
47d
101436
101397
650490
067847
654049
L580009
L50050
101453
00a
00a
101965
101966
83
Description
Qty.
Req.
STRIKER-HOOD . . . . . . . . . . . . . . . 1
STRIKER MOUNT. . . . . . . . . . . . . . 1
CS 3/8x1 C5ZY . . . . . . . . . . . . . . . . 2
HLN INST 3/8 CZY . . . . . . . . . . . . . 2
FW 3/8 ANZY. . . . . . . . . . . . . . . . . . 4
BALL JOINT/10-32 ROD END. . . . . 2
NUT, 10-32 HEX . . . . . . . . . . . . . . . 2
ROD-LINKAGE . . . . . . . . . . . . . . . . 1
-- ITEMS NOT SHOWN -FRONT AIR BAFFLE BRACKET. . . 1
REAR AIR BAFFLE BRACKET . . . . 1
a
b
c
Used on early engine covers equipped with the
two latching points.
d
Used on later engine covers equipped with the
single center latching point.
e
When equipped with air conditioning and
serial number is within note b, then use
L71355 Air Baffle.
f
Items used with this baffle, but are not shown,
include (1) 101965 Front Air Baffle Bracket and
(1) 101966 Rear Air Baffle Bracket.
907878/DP0208
Chassis
DL Series Dynalift
Battery Tray Group
1
5
6
7
9
3
6
2
8
10
4
8
11
12
13
16
15
14
Latest Style
21
Early Style
19
18
20
17
14
17
FRONT
907878/DP0208
84
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Battery Tray Group
Ref.
No.
01
02
03
Part
No.
L630004
L630003
101247
101960
101963
L70180
04
05
06
07
08
09
10
11c
12
13
14
15
16
17
102176
101961
101962
L70178
L70179
L530003
L43964
L70146
L500311
L68585
L99900
L71258
L500312
101457
L70149
L71259
L69625
L50628
L50174
L69627
L50061
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
GROUND STRAP 14GA. 14” . . . . . 1
RUBBER BOOT . . . . . . . . . . . . . . . 1
POS. BATTERY CABLE 75” . . . . . . 1
Note c (shown in illustration)
POWER PLUG (female end) . . . . . 1
#8 DUETCH PIN . . . . . . . . . . . . . . 1
Note a and b
NEG. BATTERY CABLE, 12”. . . . . . 1
Note c (shown in illustration)
POWER PLUG (male end). . . . . . . 1
#8 DUETCH SOCKET . . . . . . . . . . 1
Note a and b
NEG. BATTERY CABLE, 64”. . . . . . 1
3/8-16 WING NUT . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 1
HOLD DOWN ROD . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 1
MASTER DISCONNECT SWITCH . 1
Note a (includes key)
KEY
Note b and c (includes key)
KEY
BATTERY HANDLE, WELDMENT . 1
BATTERY HANDLE, WELDMENT . 1
Note a
Note b
BATTERY LEVER ROD. . . . . . . . . . 1
ROLL PIN .19X1 . . . . . . . . . . . . . . . 2
9/16” FLAT WASHER . . . . . . . . . . . 2
SPRING, BATTERY LEVER . . . . . . 1
3/8”-16 FLARE NUT . . . . . . . . . . . . 4
18ab
19c
20
21
L69629
101364
L69624
NSS
Description
Qty.
Req.
BATTERY TRAY WELD. . . . . . . . . . 1
BATTERY TRAY WELD. . . . . . . . . . 1
TRAY HINGE (pin). . . . . . . . . . . . . . 1
BATTERY 12 V BCI NO. 4DLT . . . . 1
---FOR SERIAL NUMBER----
85
a
b
DL6H SN 20441 Thru 20782
DL6L SN 25442 Thru 25585
DL8H SN 30420 Thru 30809
DL8L SN 35373 Thru 35492
DL10H SN 40199 Thru 40458
DL10L SN 45120 Thru 45172
DL12H SN 50123 Thru 50199
c
907878/DP0208
Chassis
DL Series Dynalift
Hydraulic Tank Group
3
2
4
1
5
6
9
7
10
8
11
25
22
23
29
26
12
24
13
27
28
18
17
21
20
16
15
14
8
19
31
30
32
For units equipped
with outriggers
907878/DP0208
86
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Hydraulic Tank Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19a
20
Part
No.
Description
L70377
L70388
L442004
L445001
L70390
L445003
L70378
L62954
L71413
L69578
L500227
L63546
L70207
L70234
L70266
L69636
L441010
L50288
L448002
L69309
L99459
L500352
L99970
L51587
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
HYDRAULIC TANK WELDMENT . . 1
TANK BREATHER . . . . . . . . . . . . . . 1
ADAP -12JICM -12NPTM 90 DEG . 1
ADAP -12ORM -12JICM 90 DEG . . 1
HOSE -10 -12JFX - 12JFX 31” . . . . 1
TANK DIFFUSER . . . . . . . . . . . . . . 1
DIPSTICK, HYDRAULIC OIL . . . . . 1
FILLER CAP ASSEMBLY . . . . . . . . 1
GASKET . . . . . . . . . . . . . . . . . . . . . 1
DIPSTICK HOUSING GROMMET . 1
HYD. OIL FILL TUBE, WELDMENT 1
2” T-BOLT BAND CLAMP . . . . . . . . 2
HOSE -24 31”. . . . . . . . . . . . . . . . . 1
HYDRAULIC PIPE. . . . . . . . . . . . . . 1
ADAP -24NPTM -24JICM STR . . . . 1
5/16-18X1/2” BOLT . . . . . . . . . . . . . 4
ADAP 1/8NPTM 1/8NPTF 45 DEG . 1
RETURN FILTER. . . . . . . . . . . . . . . 1
HYD. FILTER CARTRIDGE . . . . . . 1
O RING. . . . . . . . . . . . . . . . . . . . . . 1
RESTRICTOR SWITCH (item 32) . 1
ADAP -20ORM -20JICM STR . . . . . 1
21
22
23
24
25
26b
27
28
29
30c
31c
32
L70379
L43221
L50251
L65211
L70338
L446047
L69358
L446001
L70465
P471353
L70692
L99970
a
Return filter includes Housing, L99459 filter
cartridge, L500352 o ring and L99970 switch.
b
Use P471353 -12ORM -10JICM 90 elbow adapter
for units equipped with outriggers.
c
Used only on units equipped with outriggers.
TUBE, FILTER TO TANK. . . . . . . . . 1
1/2-14 MAGNETIC PLUG . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 4
3/8-16 CLIP RETAINING NUT. . . . . 4
SWAGELOK CONNECTOR . . . . . . 1
PLUG -12ORM . . . . . . . . . . . . . . . . 1
SUCTION STRAINER . . . . . . . . . . . 1
ADAP -32ORM -32HBARB 45 DEG 1
2-1/2” T-BOLT BAND CLAMP . . . . . 1
ADAP -12ORM -10JICM 90 . . . . . . 1
HOSE, -12 A12/NS10 51”. . . . . . . . 1
RESTRICTOR SWITCH . . . . . . . . . 1
(Included with item 19)
Hose Locator
Ref
No.
From Port
To Port
*31
HYDRAULIC TANK
V20 VALVE “OUT”
* Used only on units equipped with outriggers.
PRINTED IN U.S.A.
87
907878/DP0208
Chassis
DL Series Dynalift
Fuel Tank Group
1
2
5
4
3
7
6
8
10
9
11
12
13
FUEL
TRANSFER
PUMP
14
23 24
INJECTOR
FUEL
RETURN
20
15
19
18
16
FUEL RETURN
17
FUEL SUPPLY
907878/DP0208
88
22
21
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Fuel Tank Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
Part
No.
L70388
L442004
L70389
L446020
L70173
L79117
L69740
L69782
L69741
L69739
L69578
L500227
L50061
L50261
L441010
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
TANK BREATHER . . . . . . . . . . . . . . 1
ADAP -12JICM -12NPTM 90 DEG . 1
BREATHER HOSE . . . . . . . . . . . . . 1
ADAP -12JICFS -12JICM 90 DEG . 1
FUEL SENDER . . . . . . . . . . . . . . . . 1
BREATHER VALVE ASSEMBLY . . . 1
FUEL FILL TUBE . . . . . . . . . . . . . . . 1
1-7/8-12 JAM NUT. . . . . . . . . . . . . . 1
FUEL FILL MOUNT . . . . . . . . . . . . . 1
FILLER CAP MOUNT . . . . . . . . . . . 1
FILLER CAP ASSEMBLY . . . . . . . . 1
GASKET . . . . . . . . . . . . . . . . . . . . . 1
3/8-16 FLARE NUT . . . . . . . . . . . . . 1
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 1
ADAP -24NPTM -24JICM STR . . . . 1
15
16
17
18
19
20
21a
22b
22c
23
24
L277484
L70575
L50251
L65211
L43221
L69360
L70455
L70456
L71175
L69166
L75956
a
b
c
Refer to Engine Section for fittings
Used with JD engine.
Used with Perkins engine.
89
Description
Qty.
Req.
ADAP -8ORM -6JICM STR . . . . . . . 2
LOW FUEL SWITCH . . . . . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 4
3/8-16 CLIP RETAINING NUT. . . . . 4
1/2-14 MAGNETIC PLUG . . . . . . . . 1
FUEL TANK . . . . . . . . . . . . . . . . . . . 1
HOSE -6 A6/A5 56” FUEL LINE . . . 1
HOSE-4 A6 73” FUEL LINE . . . . . . 1
HOSE-4 A6 84” FUEL LINE . . . . . . 1
TUBE, FUEL LINE . . . . . . . . . . . . . . 1
HOSE CLAMP #10 . . . . . . . . . . . . . 1
907878/DP0208
Chassis
DL Series Dynalift
Outriggers
7
8
9
18
1
4
22
12
7
19
11
18
20
8
11
21
6
9
2
10
5
4
3
12
13
18
17
7
14
16
15
907878/DP0208
90
PRINTED IN U.S.A.
DL Series Dynalift
Chassis
Outriggers
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
Description
L70605
L50084
L50385
L444004
L70695
L70691
L50230
L69724
L70621
L70614
L10465
Qty.
Req.
OUTRIGGER FRAME WLDMNT . . 1
3/4”-10 STOVER LOCK NUT . . . . . 8
3/4”-10X3” GR8 BOLT . . . . . . . . . . . 8
ADAP -8ORM -8JICM STR . . . . . . . 4
HOSE -6 DS8/A8 68” . . . . . . . . . . . 1
HOSE -6 DS8/A8 70” . . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 16
PIVOT PIN CAP . . . . . . . . . . . . . . . 4
PIVOT PIN LEG/CYLINDER . . . . . . 4
BRONZE BUSHING . . . . . . . . . . . . 2
ZERK 1/4”-28 STR . . . . . . . . . . . . . 8
Ref.
No.
Part
No.
12
13
14
15
16
17
18
19
20
21
22
L69725
L70615
L50275
L64914
L520005
L64963
L69138
L70618
L70695
L70691
L70616
Description
Qty.
Req.
LOCK PIN CAP . . . . . . . . . . . . . . . . 4
OUTRIGGER LEG WELDMENT . . . 2
3/8”-16X3” BOLT . . . . . . . . . . . . . . . 2
OUTRIGGER LEG PAD WLDMNT . 2
3/8”-16 NYLON INSERT NUT . . . . . 2
LEG AND CYLINDER PIN. . . . . . . . 2
BRONZE BUSHING . . . . . . . . . . . . 6
BRONZE BUSHING (CYLINDER). . 2
HOSE -6 DS8/A8 68” . . . . . . . . . . . 1
HOSE -6 DS8/A8 70” . . . . . . . . . . . 1
OUTRIGGER CYLINDER . . . . . . . . 2
Hose Locator
Ref
No.
From Port
To Port
05
06
20
21
LEFT CYLINDER LOWER PORT
LEFT CYLINDER UPPER PORT
RIGHT CYLINDER UPPER PORT
RIGHT CYLINDER LOWER PORT
OUTRIGGER
OUTRIGGER
OUTRIGGER
OUTRIGGER
PRINTED IN U.S.A.
91
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
PORT “4”
PORT “3”
PORT “2”
PORT “1”
907878/DP0208
Engine
DL Series Dynalift
External Engine Components Group
WATER
32
25
SHUT-OFF
35
26
31
33
30
23
24
27
28
13
34
14
9
22
FUEL
1
14
TRANSFER
PUMP
21
10
11
15
19
20
18
17
14
3
13
14
2
4
16
8
15
5
9
ENGINE WIRE
HARNESS
12
7
6
10
11
29
907878/DP0208
92
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
NOTE:
20
All reference notes and serial breaks
are listed on the next two pages.
01
02j
03j
04aj
04b
05j
06
NSS
L64664
L50050
L64663
L71176
L580009
101250
101818
L70865
L70413
07
L64646
103626
08
09
10
11
12ac
12b
13
14
15
16
17a
17b
18a
19a
19b
L64795
L500224
L70819
L70402
L69240
L69241
L50519
L70682
L69812
L50562
L76020
L50305
L69687
L69696
101870
L69264
L99979
L50422
L70521
L63605
Part
No.
ENGINE . . . . . . . . . . . . . . . . . . . . . . 1
COUPLER, ROD TO CABLE . . . . . 1
#10-32 NUT . . . . . . . . . . . . . . . . . . . 3
THROTTLE EXTEND ROD . . . . . . . 1
THROTTLE EXTEND ROD . . . . . . . 1
BALL JOINT, #10-32 ROD END . . . 1
WIRE HARNESS (to engine) . . . . . 1
Note a and k
HARNESS (not shown) Note k
Note a, j
Note b
ENG. OIL PRES. SENDER . . . . . . . 1
Note j
Note k
TEMP. SWITCH . . . . . . . . . . . . . . . . 1
Note k (250 set)
Note a and g (235 set-Relocation Kit)
Note a and h (235 set)
Note b (225 set)
ISO MOUNT . . . . . . . . . . . . . . . . . . 2
TAIL WASHER ASSY . . . . . . . . . . . 2
ENGINE MOUNT. . . . . . . . . . . . . . . 1
ENGINE MOUNT. . . . . . . . . . . . . . . 1
3/4-10X4” GR8 BOLT . . . . . . . . . . . 2
HOSE CLAMP, #32 . . . . . . . . . . . . . 4
M16 2X35 MM BOLT . . . . . . . . . . . . 6
LOWER RADIATOR HOSE . . . . . . . 1
Note a and j
Note b
Note a and k
20” SUCTION FAN . . . . . . . . . . . . . 1
20” SUCTION FAN . . . . . . . . . . . . . 1
M8 1.25X70 MM BOLT . . . . . . . . . . 4
FAN SPACER (John Deere). . . . . . 1
FAN SPACER (Perkins). . . . . . . . . . 1
21a
22a
22b
23
L99982
L500444
L500598
NSS
656016
L69807
L69813
24
25
26
27
28
29d
30
31
32
33
34
35
L69686
L69695
101869
L70233
L50051
L41179
L50209
L50706
100751
L69718
L99966
L447005
104340
104341
NSS
00a
00b
00b
L65570
L65568
L80937
00k
00k
00k
00k
Description
Qty.
Req.
FAN BELT . . . . . . . . . . . . . . . . . . . . 1
Note e (John Deere)
Note f (John Deere)
Note i (John Deere)
(Perkins 1004-40T)
M12 1.75X30 MM BOLT . . . . . . . . . 3
ENGINE/TRANS. MOUNT . . . . . . . 1
ENGINE/TRANS. MOUNT . . . . . . . 1
UPPER RADIATOR HOSE . . . . . . . 1
Note a and j
Note b
Note a and k
RELAY MOUNT BRACKET. . . . . . . 1
1/4-20 FLANGE NUT. . . . . . . . . . . . 2
STARTER RELAY . . . . . . . . . . . . . . 1
1/4-20X1/2” BOLT . . . . . . . . . . . . . . 2
M12 1.75X20MM BOLT . . . . . . . . . . 2
ENGINE / AC COMP. MOUNT . . . . 1
ADAP, M18 -6NPTF STR . . . . . . . . 1
SHUTOFF, MANUAL/WATER . . . . . 1
ADAP, M18 10 BEAD STR . . . . . . . 1
ADAP, 5MJ -2MP90. . . . . . . . . . . . . 1
ADAP, -6 PUSHON -5FEM JIC . . . . 1
FUEL TRANSFER PUMP . . . . . . . . 1
--- ITEMS NOT SHOWN--ENGINE BLOCK HEATER . . . . . . . 1
ENGINE BLOCK HEATER . . . . . . . 1
ENGINE STARTER (Perkins) . . . . . 1
-- (JOHN DEERE TIER II ENGINE) -103862
ENGINE HARNESS / TIER 2 . . . . . 1
(on engine)
104024
BRACKET/ HARNESS MOUNT . . . 1
L50952
BOLT/M10X1.5X25 . . . . . . . . . . . . . 1
654028
7/16” LOCK WASHER . . . . . . . . . . . 1
REFER TO FUEL TANK SECTION FOR A LISTING OF FUEL
LINES.
NOTE: Please refer to the next page for reference notes and
serial breaks.
PRINTED IN U.S.A.
93
907878/DP0208
Engine
DL Series Dynalift
BLANK
907878/DP0208
94
PRINTED IN U.S.A.
DL Series Dynalift
Engine
a
b
c
d
e
f
g
Used with JD 4045 engine
Used with Perkins 1004-40T engine.
This mount has been replaced by PN 100751
(ref. 29). If the unit is equipped with air
conditioning, it will also be necessary to order
PN 100226 AC Compressor Bracket and mounting
hardware.
Replaces earlier engine mounts. If your unit used
the earlier mount (ref 12), and is equipped with air
conditioning, you will also need to order
PN 100226 AC Compressor bracket and hardware.
--- SERIAL NUMBERS --DL6L (Turbo) SN 25219 and before
DL6L (Natural) SN 25256 and before
DL6H (Turbo) SN 20211 and before
DL6H (Natural) SN 20236 and before
DL6L (Turbo) SN 25222 Thru 25599
DL6L (Natural) SN 25269 and up
DL6H (Turbo) SN 20213 Thru 20780
DL6H (Natural) SN 20237 and up
DL8L SN 35235 Thru 35496
DL8H SN 30226 Thru 30805
DL10L SN 45085 Thru 45172
DL10H SN 40104 Thru 40456
h
DL10L SN 45086 Thru SN 45184
DL10H SN 40103 Thru SN 40498
DL12H SN SN 50220 and before
i
j
k
PRINTED IN U.S.A.
95
907878/DP0208
Engine
DL Series Dynalift
Radiator Group
5
2
6
7
8
8 11
9
10
1
4
10
3
12
13
12
14
8
16
3
12
9
15
17
14
3
17
12
16
14
4
18
22
21
19
21
20
23
4
24
19 4
907878/DP0208
96
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Radiator Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10a
11
12
13
14
15
16
17
18
Part
No.
102278
102064
650490
L50056
101827
L70725
102031
L50141
650027
L69351
L50228
654049
102291
067847
L99972
101828
102292
L70629
Description
Qty.
Req.
RADIATOR . . . . . . . . . . . . . . . . . . . 1
RADIATOR CAP, 13 # PSI . . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . . 8
5/16”-18 FLARE NUT . . . . . . . . . . AR
AIR BAFFLE . . . . . . . . . . . . . . . . . . 1
SEAL TRIM/FEET (not shown) . . . . 5
FAN SHROUD . . . . . . . . . . . . . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . AR
5/16”-18X1” BOLT . . . . . . . . . . . . AR
FAN GUARD HALF 20” . . . . . . . . . 2
5/16-18X1/2” BOLT. . . . . . . . . . . . AR
3/8” FLAT WASHER . . . . . . . . . . . AR
GROMMET, RUBBER 3/8” ID . . . . . 4
3/8”-20 LOCKNUT . . . . . . . . . . . . . . 8
RADIATOR DRAIN COCK. . . . . . . . 1
RADIATOR SUPPORT . . . . . . . . . . 2
ISOLATOR, RUBBER . . . . . . . . . . . 2
ETHER KIT . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
Qty.
Req.
19
20
21
22
L50230
102066
L50051
101495
23
24
102065
L50202
5/16-18X3/4” BOLT. . . . . . . . . . . . AR
1/4-20 WHIZ LOCK NUT. . . . . . . . . 4
WINDSHIELD WASHER SYS. . . . . 1
(includes reservoir and two pumps)
WASHER BOTTLE MOUNT . . . . . . 1
1/4-20X5/8” BUTTON HD BOLT . . . 4
06
00
00
00
L70725
L70625
L70709
102262
-- ITEMS NOT SHOWN -SEAL TRIM/FEET (not shown) . . . . 5
ETHER WIRE HARNESS . . . . . . . . 1
WASHER BOTTLE HARNESS . . . . 2
OVERFLOW HOSE (42”) . . . . . . . . 1
a
Units equipped with air conditioning,
use (1) L70729 Fan Guard (not shown)
Usage Table
PRINTED IN U.S.A.
97
907878/DP0208
Engine
DL Series Dynalift
Radiator Group
5
6
7
8
4
3
6
7
2
1
9
6
7
10
11
12
16
24
7
6
14
17
13
4
18
4
4
20
14
19
22
15
21
907878/DP0208
23
98
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Radiator Group
Ref.
No.
01
02
03
04
05
06
07
08
09a
10
11
12
13
14
15
16
17
18
19
Part
No.
L69131
L99971
L99972
L70496
L69353
L50056
L70130
L50141
L50228
L70725
L69351
L70649
L50051
L50202
L70697
L50230
L70709
L70129
L70718
L69665
L50367
L520005
Description
Qty.
Req.
Ref.
No.
Part
No.
20
RADIATOR . . . . . . . . . . . . . . . . . . . 1
RADIATOR CAP, 10 # PSI . . . . . . . 1
RADIATOR PET COCK . . . . . . . . . 1
AIR BAFFLE LH . . . . . . . . . . . . . . . 1
FAN SHROUD . . . . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 8
AIR BAFFLE TOP . . . . . . . . . . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . 24
5/16-18X1/2” BOLT . . . . . . . . . . . . 24
SEAL TRIM/FEET . . . . . . . . . . . . . . 5
FAN GUARD HALF20” . . . . . . . . . . 2
WINDSHIELD WASHER SYS. . . . . 1
(includes reservoir and pump)
1/4-20 WHIZ LOCK NUT. . . . . . . . . 4
1/4-20X5/8” BUTTON HD BOLT . . . 4
WASHER BOTTLE MOUNT . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 4
WASHER BOTTLE HARNESS . . . . 1
AIR BAFFLE RH . . . . . . . . . . . . . . . 1
Note b
Note c
RADIATOR SUPPORT RH . . . . . . . 1
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 4
3/8-16 LOCK NUT . . . . . . . . . . . . . . 4
21
22
23
24
a
b
c
L70647
L71172
L70629
L510008
L70625
L69311
Description
Qty.
Req.
(four bolt holes and no tab)
(four bolt holes and tab with a slot)
ETHER KIT . . . . . . . . . . . . . . . . . . . 1
5/16-18X5/8” BOLT . . . . . . . . . . . . . 4
ETHER WIRE HARNESS . . . . . . . . 1
RADIATOR SUPPORT LH . . . . . . . 1
Units equipped with air conditioning,
use (1) L70729 Fan Guard 20” [2 halves]
(not shown)
--- SERIAL NUMBERS --DL6L SN 25216 and before
DL10L SN 45083 Thru 45184
DL10H SN 40102 Thru 40498
Usage Table
PRINTED IN U.S.A.
99
907878/DP0208
Engine
DL Series Dynalift
Air Cleaner Group
1
2
5
3
20
4
6
19
7
2
13
8
15
18
14
9
11
12
16
17
10
907878/DP0208
100
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Air Cleaner Group
01
02
03
L69584
L69714
L69793
L70467
04
05
06
07
L69570
L69795
L70468
101926
L68517
NSS
08
09
10
11
L442059
L69306
101349
L69304
12
101523
AIR INLET PIPE . . . . . . . . . . . . . . . 1
Note a
Note b
Note c
T-BOLT BAND CLAMP 3-1/2” . . . . . 3
REDUCER, STR . . . . . . . . . . . . . . . 1
Note a and b
Note c
T-BOLT BAND CLAMP 4” . . . . . . . . 1
PRECLEANER (includes item 7). . . 1
REDUCER, RUBBER 4”-3” . . . . . . . 1
HOSE CLAMP, SAE 64 . . . . . . . . . . 1
(included with item 5)
FITTING. . . . . . . . . . . . . . . . . . . . . . 1
AIR RESTRICTION INDICATOR. . . 1
FRONT PANEL, HIGH AIR . . . . . . . 1
AIR CLEANER ASSEMBLY. . . . . . . 1
BRACKET, AIR FILTER MOUNT. . . 1
13
14
15
16
17
18
L69303
L99967
L99453
L99931
L99933
L99932
AIR CLEANER MOUNT BAND . . . . 1
AIR FILTER SAFETY ELEMENT . . 1
AIR FILTER ELEMENT . . . . . . . . . . 1
END COVER ASSEMBLY . . . . . . . . 1
LATCH . . . . . . . . . . . . . . . . . . . . . . 3
EVACUATOR VALVE. . . . . . . . . . . . 1
RUBBER ELBOW 90 DEG . . . . . . . 1
Note a
Note b
Note c
INTAKE PIPE BRACKET. . . . . . . . . 1
HOSE CLAMP, #52 . . . . . . . . . . . . . 1
19
20
L63439
L120041
L69796
L66594
L51099
a
b
c
d
Used with JD Natural engine
Used with JD Turbo engine
Used with Perkins engine
Refer to Usage Table below
Usage Table
PRINTED IN U.S.A.
101
907878/DP0208
Engine
DL Series Dynalift
Air Cleaner Group
1
2
4
6
5
3
3
7
9
8
10
14
17
13
12
3
12
16
15
11
18
19
21
22
20
23
24
907878/DP0208
102
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Air Cleaner Group
Ref.
No.
01
02d
03
04d
05d
06d
07d
08
09d
10
Part
No.
L70718
L64787
L51099
L70653
101682
L70652
L70656
L70657
L70684
L70686
L60492
L69584
L69714
L69793
11
12
L63439
L120041
L69796
L70467
Description
Qty.
Req.
AIR BAFFLE/INLET. . . . . . . . . . . . . 1
STRAIGHT ADAPTER. . . . . . . . . . . 1
HOSE CLAMP, #52 . . . . . . . . . . . . . 4
PRE-CLEANER PIPE . . . . . . . . . . . 1
PRE-CLEANER (Turbo III) . . . . . . . 1
AIR CLEANER PIPE . . . . . . . . . . . . 1
PRE-CLEANER MOUNT. . . . . . . . . 1
PRE-CLEANER SUPPORT. . . . . . . 1
Note a, b and d
Note c and d
SPACER (Note c and d) . . . . . . . . . 1
CLAMP, 3” . . . . . . . . . . . . . . . . . . . . 2
AIR INLET PIPE . . . . . . . . . . . . . . . 1
Note a
Note b
Note c
Note a
Note b
Note c
T-BOLT BAND CLAMP 3-1/2” . . . . . 3
Ref.
No.
Part
No.
13
14
L66594
15
16
17
18
19
20
21
22
23
L69570
L69795
L70468
L69306
L442059
L69304
Description
Qty.
Req.
REDUCER, STR . . . . . . . . . . . . . . . 1
Note a and b
Note c
T-BOLT BAND CLAMP 4” . . . . . . . . 1
AIR RESTRICTION INDICATOR. . . 1
FITTING. . . . . . . . . . . . . . . . . . . . . . 1
AIR CLEANER BRACKET. . . . . . . . 1
LATCH . . . . . . . . . . . . . . . . . . . . . . 3
EVACUATOR VALVE. . . . . . . . . . . . 1
24
L69303
L70726
L99967
L99453
L99931
L99933
L99932
a
b
c
d
Usage Table
DL10L SN 45083 Thru SN 45184
DL10H SN 40102 Thru SN 40498
PRINTED IN U.S.A.
103
907878/DP0208
Engine
DL Series Dynalift
Air Cleaner Group
1
2
9
3
8
4
5
2
6
10
7
4
21
6
11
20
18
19
17
15
16
14
13
12
907878/DP0208
104
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Air Cleaner Group
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
L69584
L69714
L69793
L70467
L69570
L69795
L70468
L70461
L51781
L70470
L51099
L66594
L63439
L120041
L69796
Description
Qty.
Req.
AIR INLET PIPE . . . . . . . . . . . . . . . 1
Note a
Note b
Note c
T-BOLT BAND CLAMP 3-1/2” . . . . . 3
REDUCER, STR . . . . . . . . . . . . . . . 1
Note a and b
Note c
T-BOLT BAND CLAMP 4” . . . . . . . . 1
INLET ADAPTER HOSE . . . . . . . . . 1
HOSE CLAMP #72 . . . . . . . . . . . . . 2
INLET TUBE . . . . . . . . . . . . . . . . . . 1
HOSE CLAMP, #52 . . . . . . . . . . . . . 1
Note a
Note b
Note c
Ref.
No.
Part
No.
Description
11
12
13
14
15
16
17
18
L68516
L99932
L99931
L99933
L99453
L99967
L70443
L69303
L69304
19
20
21
L69306
L442059
L49725
a
b
c
d
Qty.
Req.
PRE-CLEANER . . . . . . . . . . . . . . . . 1
VACUATOR VALVE . . . . . . . . . . . . . 1
LATCH . . . . . . . . . . . . . . . . . . . . . . 3
MOUNT BRACKET . . . . . . . . . . . . . 1
(includes Items 12-15)
RESTRICTION INDICATOR . . . . . . 1
FITTING. . . . . . . . . . . . . . . . . . . . . . 1
MUFFLER CLAMP 4” . . . . . . . . . . . 1
Usage Table
DL12H N/A
PRINTED IN U.S.A.
105
907878/DP0208
Engine
DL Series Dynalift
Engine Muffler Group
Engine Exhaust Pipes
1
19
4
3
18
17
2
2
5
16
4
20
JD Natural
JD Turbo
Perkins
6
7
8
9
13
10
11
12
15
14
13
907878/DP0208
106
PRINTED IN U.S.A.
DL Series Dynalift
Engine
Engine Muffler Group
Ref.
No.
Part
No.
01
02a
03
04
05
06
07
08
09
10
11
12
13
14
15
L70325
L120047
L70333
L520004
L70335
L50061
L64764
L50251
L70324
L50856
L69540
L69538
L60492
L50757
L69567
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
VERTICAL TAIL PIPE . . . . . . . . . . . 1
2-1/2” MUFFLER CLAMP . . . . . . . 1*
TAIL PIPE BRACKET . . . . . . . . . . . 1
ISO MOUNT . . . . . . . . . . . . . . . . . . 1
3/8-16 FLARE NUT . . . . . . . . . . . . 1
FLEXIBLE BRACKET . . . . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . 1
HORIZONTAL TAIL PIPE . . . . . . . . 1
3-1/2” MUFFLER CLAMP . . . . . . . . 1
OVAL MUFFLER . . . . . . . . . . . . . . . 1
MUFFLER BRACKET . . . . . . . . . . . 1
3” MUFFLER CLAMP . . . . . . . . . . . 3
M10 1.5X39 MM BOLT . . . . . . . . . . 2
MUFFLER PIPE . . . . . . . . . . . . . . . 1
16b
17b
18c
19a
20a
L99434
L69712
L70412
L69791
L69794
TURBO CLAMP. . . . . . . . . . . . . . . . 1
OUTLET EXH PIPE (JD Turbo). . . . 1
OUTLET EXH PIPE (JD Natural) . . 1
EXHAUST PIPE (Perkins) . . . . . . . . 1
OUTLET EXH PIPE (Perkins) . . . . . 1
00b
L71314
-- ITEMS NOT SHOWN -CATALYTIC PURIFIER (option) . . .1
(used for reducing emissions)
a
b
c
*
Quantity is 2 for units with Perkins engine.
107
Description
Qty.
Req.
907878/DP0208
Transfer Case
DL Series Dynalift
Transfer Case External Components
3
2
1
5
4
2
18
18
17
6
16
15
14
13
7
8
12
11
10
9
907878/DP0208
108
PRINTED IN U.S.A.
DL Series Dynalift
Transfer Case
Transfer Case External Components
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L50367
L50820
L69400
L99825
L99799
L99800
L50368
L50562
L50519
PRINTED IN U.S.A.
Description
Qty.
Req.
3/8-16x1” BOLT . . . . . . . . . . . . . . . . 8
3/8” HARDENED WASHER . . . . . 14
FLEXIBLE COUPLING . . . . . . . . . . 1
SHAFT ADAPTER . . . . . . . . . . . . . . 1
HUB ADAPTER` . . . . . . . . . . . . . . . 1
DRIVEN PLATE ASY. . . . . . . . . . . . 1
3/8-16X1-1/4” BOLT . . . . . . . . . . . 12
3/4-10X4” BOLT. . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
10
11
12
13
14
15
16
17
18
L69241
L69240
L69324
L69123
L69265
L50359
L50952
L50727
L50819
109
Description
Qty.
Req.
TAIL WASHER. . . . . . . . . . . . . . . . . 2
CENTER BONDED MOUNT . . . . . . 2
CASE MOUNT BAR . . . . . . . . . . . . 1
TRANSFER CASE ASY. . . . . . . . . . 1
CASE MOUNT WELDMENT . . . . . . 1
5/8-11X1/1/4” BOLT . . . . . . . . . . . . . 4
M10 1.5X25 MM BOLT . . . . . . . . . . 8
M10 1.5X35 MM BOLT . . . . . . . . . . 4
3/8-24X3/4” BOLT . . . . . . . . . . . . . 14
907878/DP0208
Transfer Case
DL Series Dynalift
Transfer Case Assembly Group
Part 1 of 2
2
1
3
4,5
25
24
11-13
6
17
18-20
14-16
7-9
10
23
4,5
21
22
907878/DP0208
110
PRINTED IN U.S.A.
DL Series Dynalift
Transfer Case
Part 1 of 2
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
Part
No.
L99828
L99829
L99800
L99797
L50592
L50152
L99818
L99809
L99810
L99811
L99823
L99798
L50823
L50143
PRINTED IN U.S.A.
Description
Qty.
Req.
EXTERNAL RETAINING RING . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
DRIVEN PLATE ASY. . . . . . . . . . . . 1
TRANSMISSION. ADAPTER . . . . . 1
1/2-13X1-1/2” GR8 BOLT . . . . . . . 12
1/2” LOCK WASHER . . . . . . . . . . . 12
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
INPUT/OUTPUT SHIM .007 . . . . . . 8
1/2” NPT PLUG . . . . . . . . . . . . . . . . 3
END-INTERM. CAP. . . . . . . . . . . . . 2
5/16-18X1” BOLT. . . . . . . . . . . . . . 12
5/16” LOCK WASHER . . . . . . . . . 12
Ref.
No.
Part
No.
14
15
16
17
18
19
20
21
22
23
24
25
L99812
L99813
L99814
NSS
L50368
L50145
L50066
L99819
L99796
L69400
L99799
L67379
111
Description
Qty.
Req.
IDLERS SHIM .005 . . . . . . . . . . . . . 8
IDLERS SHIM .007 . . . . . . . . . . . . . 8
IDLERS SHIM .020 . . . . . . . . . . . . . 2
HOUSING SUB-ASY. . . . . . . . . . . . 1
3/8-16X1-1/4” GR8 BOLT . . . . . . . 14
3/8 FLAT WASHER . . . . . . . . . . . 14
3/8-16 GR8 NUT . . . . . . . . . . . . . 14
DOWEL PIN. . . . . . . . . . . . . . . . . . . 2
ADAPTER, SAE #3 . . . . . . . . . . . . . 1
FLEXIBLE COUPLING . . . . . . . . . . 1
HUB ADAPTER . . . . . . . . . . . . . . . . 1
EXTERNAL RETAINER RING. . . . . 2
907878/DP0208
Transfer Case
DL Series Dynalift
Part 2 of 2
1
2,3
4
5,6
7,8
2,3
2,3
12
13,6
5,6
14
2,3
9
21
20
10
1
2,3
4
13,6
11
19
18
2,3
15
16
17
907878/DP0208
112
PRINTED IN U.S.A.
DL Series Dynalift
Transfer Case
Part 2 of 2
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L99817
L99805
520013
L99807
L99801
L99816
L99826
L99827
L99820
L99821
L99824
PRINTED IN U.S.A.
Description
Qty.
Req.
HIGH TEMP. VITON SEAL . . . . . . . 2
BEARING CONE . . . . . . . . . . . . . . . 8
BEARING CUP . . . . . . . . . . . . . . . . 8
OUTER SPACER. . . . . . . . . . . . . . . 2
RH GEAR (84 TEETH) . . . . . . . . . . 2
KEY . . . . . . . . . . . . . . . . . . . . . . . . . 4
OUTPUT SHAFT . . . . . . . . . . . . . . . 1
KEY . . . . . . . . . . . . . . . . . . . . . . . . . 1
BREATHER . . . . . . . . . . . . . . . . . . . 1
3/8” TO 3/4” BUSHING . . . . . . . . . . 1
3/4” NPT STREET ELBOW . . . . . . . 1
Ref.
No.
Part
No.
12
13
14
15
16
17
18
19
20
21
L99808
L99802
L99804
NSS
L99823
L99822
L99815
L99803
L99825
L67379
113
Description
Qty.
Req.
IDLER SPACER. . . . . . . . . . . . . . . . 4
LH GEAR (79 TEETH). . . . . . . . . . . 2
IDLER SHAFT . . . . . . . . . . . . . . . . . 2
HOUSING SUB-ASY.. . . . . . . . . . . . 1
1/2” NPT PLUG . . . . . . . . . . . . . . . . 3
1/2” NPT MAGNETIC PLUG . . . . . . 1
EXPANSION PLUG . . . . . . . . . . . . . 1
INPUT SHAFT . . . . . . . . . . . . . . . . . 1
SHAFT ADAPTER . . . . . . . . . . . . . . 1
EXTERNAL RETAINER RING. . . . . 2
907878/DP0208
Transmission
DL Series Dynalift
Transmission and Drive Shafts Group
2
3
4
1
5
6
7
8
11
10
10
9
16
15
12
13
14
17
Transmission Controller
(located in cab’s storage
compartment)
20
19
907878/DP0208
114
18
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Transmission and Drive Shafts Group
Ref.
No.
Part
No.
Description
01
02
03
04
05
06
07
08
TRANSMISSION ASY . . . . . . . . . . . 1
(Turbo equipped engines) Note c
(Natural engines) Note c
(Turbo equipped engines) Note d
ADAP -12ORM -8NPTF. . . . . . . . . . 1
TEMP. SENDER . . . . . . . . . . . . . . . 1
HOSE -12 A12/DL12 44” . . . . . . . . . 1
Note a
Note b
ADAP 1/8NPTF -10ORM. . . . . . . . . 1
REV. PRESSURE SWITCH . . . . . . 1
FRONT DRIVE SHAFT . . . . . . . . . . 1
Used with 26.25 and 26.28 axles
Used with 26.48 axle
REAR DRIVE SHAFT . . . . . . . . . . . 1
Used with 26.25 and 26.28 axles
Used with 26.48 axle
M10X1.0/45MM GR10.9 BOLT . . . . 8
(metric used on axle end)
3/8-24X1-3/4” GR8 BOLT . . . . . . . . 8
UNIVERSAL JOINT . . . . . . . . . . . . 4
3/8-24X1-3/4” GR8 BOLT . . . . . . . 16
3/8” LOCK WASHER . . . . . . . . . . . 16
ADAP -12ORM -12JICM . . . . . . . . . 1
HOSE -12 A12/A12 35” . . . . . . . . . . 1
CV WIRE HARNESS. . . . . . . . . . . . 1
ADAP -16ORM -12JICM STR. . . . . 1
DIPSTICK TUBE ASSEMBLY . . . . . 1
(Dipstick only not sold separately)
CONTROLLER, APC70/71 . . . . . . . 1
Note c
Note d
WIRE HARNESS (not shown). . . . . 1
1/4”-20X3/8” BOLT . . . . . . . . . . . . . 4
ISO MOUNT, RUBBER . . . . . . . . . 4
1/4”-20 WHIZ NUT . . . . . . . . . . . . AR
100403
100404
104867
L446014
L64795
L70087
102110
L445001
L445007
L70133
L69735
100263
09
10
11
12
13
14
15
16
L69736
100264
L50873
L50468
L99182
L50468
L50147
L444001
L70083
L70232
L64853
L71412
17
18cd
19cd
20
Qty.
Req.
L70359
104868
L70404
L50645
L70448
L50051
Ref.
No.
Part
No.
Description
00
L500375
a
b
c
d
Qty.
Req.
-- ITEMS NOT SHOWN -TEST ADAPTER . . . . . . . . . . . . . . . 1
(for checking pressure)
AXLE REFERENCE TABLE
26.25 and 26.28 axles used with the following:
DL6L Thru SN 25587
DL6H Thru SN 20803
DL8L Thru SN 35492
DL8H Thru SN 30813
DL10L Thru SN 45172
DL10H Thru SN 40459
DL12H Thru SN 50199
26.48 axles used with the following:
Hose Locator
04
13
TRANSMISSION “UPPER PORT”
TRANSMISSION “LOWER PORT”
PRINTED IN U.S.A.
OUTER COOLER UPPER PORT
OUTER COOLER LOWER PORT
115
907878/DP0208
Transmission
DL Series Dynalift
Converter Housing Group
907878/DP0208
116
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Converter Housing Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
14
15
16
17
18
19
20
21
22
Part
No.
L99661
L99662
L99663
L99664
L99665
L99666
L99667
L99668
L99669
L99670
L99671
L99672
L99673
L99674
L99675
L99676
L99029
L99677
L99678
L99029
PRINTED IN U.S.A.
Description
Qty.
Req.
CONVERTER HSG. ASY. . . . . . . . . 1
BALL . . . . . . . . . . . . . . . . . . . . . . . . 1
BY-PASS SPRING. . . . . . . . . . . . . . 1
PLUG O-RING (Part of Item 5) . . . . 1
PLUG (Incls. Item 4) . . . . . . . . . . . . 1
BALL . . . . . . . . . . . . . . . . . . . . . . . . 1
SAFETY VALVE SPRING . . . . . . . . 1
PLUG O-RING (Part of Item 9) . . . . 1
PLUG (Includes.item 8) . . . . . . . . . . 1
PLUG O-RING (Part of item 11) . . . 3
PLUG (Includes.item 10) . . . . . . . . . 3
PLUG O-RING (Part of Item 15) . . 10
PLUG (Includes.item 14) . . . . . . . . 10
FILTER ADAPTER O-RING. . . . . . . 1
FILTER ADAPTER O-RING. . . . . . . 1
FILTER ADAPTER. . . . . . . . . . . . . . 1
SCREW LOCKWASHER. . . . . . . . . 3
ADAPTER SCREW . . . . . . . . . . . . . 3
OIL BAFFLE . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
L99679
L99029
L99269
L99681
L99682
L99029
L99679
L99683
L99680
L98312
L99029
L99045
L99029
L99285
L99029
L99684
L99685
L99440
117
Description
Qty.
Req.
MOUNTING SCREW. . . . . . . . . . . . 2
MOUNTING SCREW. . . . . . . . . . . . 1
SUCT. TUBE O-RING . . . . . . . . . . . 1
SUCTION TUBE ASY. . . . . . . . . . . 1
MOUNTING SCREW. . . . . . . . . . . . 2
CASE GASKET . . . . . . . . . . . . . . . . 1
CASE O-RING. . . . . . . . . . . . . . . . . 2
CASE O-RING. . . . . . . . . . . . . . . . . 2
SCREW LOCKWASHER. . . . . . . . 14
CASE SCREW . . . . . . . . . . . . . . . 14
CASE SCREW . . . . . . . . . . . . . . . . 1
CASE SCREW . . . . . . . . . . . . . . . . 5
FRONT OUTPUT SHAFT SEAL . . . 1
FILTER ASY. . . . . . . . . . . . . . . . . . . 1
907878/DP0208
Transmission
DL Series Dynalift
Case Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
L99686
L99786
L99672
L99673
L99687
L99688
L99670
L99671
L98425
L94770
907878/DP0208
Description
Qty.
Req.
CASE ASSEMBLY. . . . . . . . . . . . . . 1
CASE/HOUSING PIN . . . . . . . . . . . 2
PLUG O-RING (Part of item 4) . . . . 1
PLUG (Incls. Item 3) . . . . . . . . . . . . 1
PLUG O-RING (Part of item 6) . . . . 1
PLUG (Includes.item 5) . . . . . . . . . . 1
PLUG O-RING (Part of item 8) . . . 11
PLUG (Includes.item 7) . . . . . . . . . 11
MAGNETIC DRAIN PLUG. . . . . . . . 1
BEARING SNAP RING . . . . . . . . . . 1
Ref.
No.
Part
No.
11
12
13
14
15
16
17
18
19
L94818
L99689
L99685
L99690
L99029
L99285
L99029
L99285
L99691
118
Description
Qty.
Req.
PLUG GASKET . . . . . . . . . . . . . . . . 1
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
REAR SHAFT SEAL . . . . . . . . . . . . 1
SHAFT BORE PLUG. . . . . . . . . . . . 1
CASE SCREW LOCKWASHER . . . 5
CASE SCREW . . . . . . . . . . . . . . . . 5
CASE SCREW LOCKWASHER . . . 4
CASE SCREW . . . . . . . . . . . . . . . . 4
STUD . . . . . . . . . . . . . . . . . . . . . . . . 4
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Torque Converter
1
2
Ref.
No.
Part
No.
01
02
L500440
L99441
L99693
PRINTED IN U.S.A.
Description
Qty.
Req.
CONVERTER & BUSHING ASY.. . . 1
Note a
Note b
PILOT BUSHING . . . . . . . . . . . . . . . 1
Ref.
No.
a
b
119
Part
No.
Description
Qty.
Req.
Used with turbo charged engines.
Used with naturally aspirated engines.
907878/DP0208
Transmission
DL Series Dynalift
Charging Pump
2
1
5
4
3
Ref.
No.
Part
No.
01
L99702
02
L99703
907878/DP0208
Description
Qty.
Req.
CHARGE PUMP ASY. . . . . . . . . . . . 1
(Includes. items 2 & 3)
PUMP O-RING . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
03
04
05
L99704
L99705
L99706
120
Description
Qty.
Req.
PUMP OIL SEAL . . . . . . . . . . . . . . . 1
PUMP MTG. SCREW . . . . . . . . . . . 6
SCREW SEAL WASHER . . . . . . . . 6
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Pump Drive
6
5
4
3
2
1
Ref.
No.
01
02
03
Part
No.
L99694
L99695
L94856
PRINTED IN U.S.A.
Description
Qty.
Req.
PUMP DRIVE SHAFT . . . . . . . . . . . 1
PISTON RING . . . . . . . . . . . . . . . . . 1
DRIVE SHAFT BEARING . . . . . . . . 1
Ref.
No.
Part
No.
04
05
06
L99696
L99697
L99698
121
Description
Qty.
Req.
BEARING RETAINING RING . . . . . 1
HOLE COVER GASKET . . . . . . . . . 1
907878/DP0208
Transmission
DL Series Dynalift
Fwd. Low/High Shaft and Gears Group
907878/DP0208
122
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Fwd. Low/High Shaft and Gears Group
(For Serial Numbers Listed Below)
Ref.
No.
Part
No.
01
02
L99707
L99708
03
L96065
04
L96066
05
06
07
08
09
10
11
12
13
14
15
16
17
L99709
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L99715
L96060
L99716
L99717
L99708
18
L96065
19
L96066
20
21
L99709
L99710
Description
Qty.
Req.
DRUM & PLUG ASY. . . . . . . . . . . . 1
PISTON & SEALS ASY. . . . . . . . . . 1
(Includes.items 3 & 4)
PISTON OUTER SEAL . . . . . . . . . . 1
(Part of Item 2)
PISTON INNER SEAL. . . . . . . . . . . 1
(Part of item 2)
PISTON WEAR PLATE . . . . . . . . . . 1
PISTON RETURN SPRING . . . . . . 1
SPRING RETAINER . . . . . . . . . . . . 1
RETAINER SNAP RING . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
DISC BACKING PLATE. . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
PLATE SPACER . . . . . . . . . . . . . . . 1
SPACER SNAP RING . . . . . . . . . . . 1
PISTON & SEALS ASY.. . . . . . . . . . 1
(Part of item 17)
(Part of item 17)
Ref.
No.
Part
No.
22
23
24
25
26
27
28
29
30
31
32
33
34
35
L99711
L94849
L99712
L99713
L99714
L99712
L99718
L96060
L98266
L99719
L99720
L99721
L94898
L99722
36
37
38
39
40
41
42
43
44
45
46
47
L98266
L99723
L99724
L99725
L99726
L99727
L99728
L99727
L99726
L99725
L99729
L99730
Description
Qty.
Req.
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 4
OUTER DISC . . . . . . . . . . . . . . . . . 3
OUTER HALF DISC . . . . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
FWD. LOW CLUTCH GEAR (54T) . 1
GEAR PISTON RING . . . . . . . . . . . 1
FL BRG. LOCATING RING . . . . . . . 2
FL GEAR INNER BEARING . . . . . . 1
GEAR OUTER BEARING . . . . . . . . 1
(Shield Out)
FWD. DRIVEN GEAR (42T) . . . . . . 1
FL/FH SHAFT FRONT BRG. . . . . . . 1
THRUST BEARING SPACER . . . . . 1
FH GEAR THRUST BEARING . . . . 1
FH GEAR NEEDLE BEARING . . . . 1
FH CLUTCH GEAR (34T) . . . . . . . . 1
FL/FH SHAFT REAR BEARING . . . 1
FL/FH SHAFT PISTON RING . . . . . 3
Serial Number Breaks
PRINTED IN U.S.A.
123
907878/DP0208
Transmission
DL Series Dynalift
Forward Low/High Shaft and Gears Group
907878/DP0208
124
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Forward Low/High Shaft and Gears Group
Ref.
No.
Part
No.
01
02
L500601
L99708
03
L96065
04
L96066
05
06
07
08
09
10
11
12
13
L99709
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L500602
14
L500603
15
16
L96060
L99708
17
L96065
18
L96066
19
L99709
Description
Qty.
Req.
DRUM & PLUG ASY. . . . . . . . . . . . 1
PISTON & SEALS ASY. . . . . . . . . . 1
(Included in item 2)
(Includes item 2)
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
END PLATE AND SEAL ASY . . . . . 1
(Includes item 14)
BACKING PLATE SEAL . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
PISTON & SEALS ASY.. . . . . . . . . . 1
Ref.
No.
Part
No.
20
21
22
23
24
25
26
27
28
29
30
31
32
33
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L99718
L96060
L98266
L500604
L99721
L94898
L99722
34
35
36
37
38
39
40
41
42
43
44
45
L98266
L99723
L99724
L99725
L99726
L99727
L99728
L99727
L99726
L99725
L99729
L99730
Description
Qty.
Req.
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 4
OUTER DISC . . . . . . . . . . . . . . . . . 3
OUTER HALF DISC . . . . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
FWD. LOW CLUTCH GEAR (54T) . 1
FL BRG. LOCATING RING . . . . . . . 2
FL GEAR INNER BEARING . . . . . . 1
GEAR OUTER BEARING . . . . . . . . 1
(Shield Out)
FWD. DRIVEN GEAR (42T) . . . . . . 1
FL/FH SHAFT FRONT BRG. . . . . . . 1
FH CLUTCH GEAR (34T) . . . . . . . . 1
FL/FH SHAFT REAR BEARING . . . 1
FL/FH SHAFT PISTON RING . . . . . 3
DL8H SN 30700and up
PRINTED IN U.S.A.
125
907878/DP0208
Transmission
DL Series Dynalift
Reverse 1st Shaft and Gears Group
907878/DP0208
126
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Ref.
No.
Part
No.
01
02
L99731
L99708
03
L96065
04
L96066
05
06
07
08
09
10
11
12
13
14
15
16
17
L99709
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L99715
L96060
L99716
L99717
L99708
18
19
20
21
L96065
L96066
L99732
L99787
22
L94849
Description
Qty.
Req.
R/1 SHAFT DRUM & PLUG ASY. . . 1
PISTON & SEALS ASY. . . . . . . . . . 1
(Part of item 2)
(Part of item 2)
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
BACKING PLATE SNAP RING . . . . 1
BACKING PLATE SPACER. . . . . . . 1
SPACER SNAP RING . . . . . . . . . . . 1
PISTON & SEALS ASY.. . . . . . . . . . 1
OUTER SEAL (Part of item 17). . . . 1
INNER SEAL (Part of item 17) . . . . 1
RETURN SPRING. . . . . . . . . . . . . . 1
(Bellevile Washer)
SNAP RING . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
23
24
25
26
27
28
29
30
31
32
33
34
35
L99712
L99713
L99714
L99712
L99733
L99718
L96060
L98266
L99719
L99720
L99721
L94898
L99722
36
37
38
39
40
41
42
L98266
L99734
L99724
L99735
L99736
L99737
L99738
43
44
45
L99739
L99740
L99730
Description
Qty.
Req.
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
MODULATION SPRING . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
REV. CLUTCH GEAR (54T) . . . . . . 1
GEAR PISTON RING . . . . . . . . . . . 1
R GEAR LOCATING RING . . . . . . . 2
R GEAR INNER BEARING . . . . . . . 1
R GEAR OUTER BEARING . . . . . . 1
(Shield Out)
REV. DRIVEN GEAR (50T) . . . . . . . 1
R/1 SHAFT FRONT BEARING . . . . 1
1ST CLUTCH GEAR (30T) . . . . . . . 1
BEARING LOCATING RING . . . . . . 2
1ST GEAR INNER BEARING . . . . . 1
1ST GEAR OUTER BEARING . . . . 1
(Shield Out)
R/1 SHAFT REAR BEARING . . . . . 1
R/1 SHAFT PISTON RING . . . . . . . 3
PRINTED IN U.S.A.
127
907878/DP0208
Transmission
DL Series Dynalift
907878/DP0208
128
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Ref.
No.
Part
No.
01
02
L500605
L99708
03
L96065
04
L96066
05
06
07
08
09
10
11
12
13
L99709
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L500602
14
L500603
15
16
L96060
L99708
17
L96065
18
L96066
19
L99709
Description
Qty.
Req.
DRUM & PLUG ASY. . . . . . . . . . . . 1
PISTON & SEALS ASY. . . . . . . . . . 1
(Includes item 2)
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
END PLATE AND SEAL ASY . . . . . 1
(Includes item 14)
BACKING PLATE SEAL . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
PISTON & SEALS ASY.. . . . . . . . . . 1
(Include in item 16)
Ref.
No.
Part
No.
20
L99787
21
22
23
24
25
26
27
28
29
30
31
32
33
L94849
L99712
L99713
L99714
L99712
L99733
L99718
L96060
L98266
L500604
L99721
L94898
L99722
34
35
36
37
38
39
40
L98266
L99734
L99724
L99735
L99736
L99737
L99738
41
42
43
L99739
L500600
L99730
Description
Qty.
Req.
RETURN SPRING. . . . . . . . . . . . . . 1
(Bellevile Washer)
SNAP RING . . . . . . . . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
INNER DISC . . . . . . . . . . . . . . . . . . 8
OUTER DISC . . . . . . . . . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
PLATE SNAP RING. . . . . . . . . . . . . 1
REV. CLUTCH GEAR (54T) . . . . . . 1
R GEAR LOCATING RING . . . . . . . 2
R GEAR INNER BEARING . . . . . . . 1
R GEAR OUTER BEARING . . . . . . 1
(Shield Out)
REV. DRIVEN GEAR (50T) . . . . . . . 1
R/1 SHAFT FRONT BEARING . . . . 1
1ST CLUTCH GEAR (30T) . . . . . . . 1
1ST GEAR INNER BEARING . . . . . 1
1ST GEAR OUTER BEARING . . . . 1
(Shield Out)
R/1 SHAFT REAR BEARING . . . . . 1
R/1 SHAFT PISTON RING . . . . . . . 3
DL8H SN 30700and up
PRINTED IN U.S.A.
129
907878/DP0208
Transmission
DL Series Dynalift
2nd Shaft Group
907878/DP0208
130
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
2nd Shaft Group
Ref.
No.
Part
No.
01
L99745
02
L99708
03
L96065
04
L96066
05
06
07
08
09
10
11
12
13
14
L99709
L99710
L99711
L94849
L99712
L99713
L99714
L99712
L99733
L99718
PRINTED IN U.S.A.
Description
Qty.
Req.
2ND SHAFT, HUB
DRUM & PLUG ASY. . . . . . . . . . . . 1
PISTON & SEALS ASY. . . . . . . . . . 1
(Part of item 2)
(Part of item 2)
SPRING RETAINER . . . . . . . . . . . . 1
OUTER HALF DISC . . . . . . . . . . . . 1
CLUTCH INNER DISC . . . . . . . . . . 8
CLUTCH OUTER DISC. . . . . . . . . . 7
OUTER HALF DISC . . . . . . . . . . . . 1
Ref.
No.
Part
No.
15
16
17
18
19
L96060
L99746
L99736
L99737
L99738
20
21
22
23
24
L99747
L99740
L99730
L99748
L99749
25
L99750
26
27
28
L99751
L99752
L99753
131
Description
Qty.
Req.
BACKING PLATE SNAP RING . . . . 1
2ND CLUTCH GEAR (52T). . . . . . . 1
2ND GEAR INNER BEARING. . . . . 1
2ND GEAR OUTER BRG. . . . . . . . . 1
(Shield Out)
BEARING SUPPORT WASHER . . . 1
2ND SHAFT FRONT BEARING . . . 1
2ND SHAFT PISTON RING . . . . . . 2
GEAR RETAINER SNAP RING. . . . 1
LOWER OUTPUT
DRIVE GEAR (41T) . . . . . . . . . . . . 1
UPPER OUTPUT
DRIVE GEAR (59T) . . . . . . . . . . . . 1
2ND SHAFT REAR BEARING . . . . 1
OUTPUT FLANGE WASHER . . . . . 1
OUTPUT FLANGE NUT . . . . . . . . . 1
907878/DP0208
Transmission
DL Series Dynalift
Input Shaft Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L99741
L99742
L99743
L98266
L99696
Note a
L99730
L98266
L99744
L99740
L99730
907878/DP0208
Description
Qty.
Req.
INPUT SHAFT . . . . . . . . . . . . . . . . . 1
F/L GEAR SNAP RING . . . . . . . . . . 1
FWD/LOW GEAR (26T) . . . . . . . . . 1
GEAR SNAP RING . . . . . . . . . . . . . 1
SHAFT FRONT BEARING . . . . . . . 1
SHAFT PISTON RING . . . . . . . . . . 1
F/H GEAR SNAP RING. . . . . . . . . . 1
FWD/HIGH GEAR (62T) . . . . . . . . . 1
INPUT SHAFT REAR BRG.. . . . . . . 1
a
132
DL6H Thru SN 20728, use PN L99740
DL6H SN 20729 and up, use PN L500600
DL6L Thru SN 25561, use PN L99740
DL6L SN 25562 and up, use PN L500600
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Output Shaft Group
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L99754
L99755
L99756
L99757
L99756
L99758
L99763
PRINTED IN U.S.A.
Description
Qty.
Req.
OUTPUT SHAFT ASY. . . . . . . . . . . 1
SHAFT FRONT BEARING . . . . . . . 1
SNAP RING . . . . . . . . . . . . . . . . . . . 1
OUTPUT SHAFT GEAR . . . . . . . . . 1
SNAP RING . . . . . . . . . . . . . . . . . . . 1
SHAFT REAR BEARING. . . . . . . . . 1
Ref.
No.
Part
No.
08
09
10
11
12
13
L99759
L99760
L99761
L99762
L99752
L99753
133
Description
Qty.
Req.
SNAP RING . . . . . . . . . . . . . . . . . . . 1
OUTPUT FLANGE SPACER . . . . . . 1
OUTPUT FLANGE. . . . . . . . . . . . . . 2
FLANGE O-RING . . . . . . . . . . . . . . 2
FLANGE WASHER . . . . . . . . . . . . . 2
FLANGE NUT . . . . . . . . . . . . . . . . . 2
907878/DP0208
Transmission
DL Series Dynalift
Drive Plate Group
Ref.
No.
Part
No.
01
L99784
02
NSS
907878/DP0208
Description
Qty.
Req.
DRIVE PLATE ASY. . . . . . . . . . . . . . 1
(Includes items 2-5.)
DRIVE PLATE (Included w/item 1.). 2
Ref.
No.
Part
No.
03
04
05
L97516
L99030
L99785
134
Description
Qty.
Req.
PLATE BACKING RING . . . . . . . . . 1
MOUNTING SCREW. . . . . . . . . . . . 6
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Control Valve Mounting Group
Ref.
No.
Part
No.
01
02
03
04
105082
L99764
L99765
L99766
L99767
05
06
L99768
L94824
PRINTED IN U.S.A.
Description
Qty.
Req.
CONTROL VALVE ASSEMBLY. . . . 1
Note a
Note b
VALVE MOUNTING SCREW . . . . . 2
PROTECTION COVER SEAL . . . . . 1
PROTECTION COVER ASY. . . . . . 1
(Includes.item 6)
COVER SCREW . . . . . . . . . . . . . . 20
AIR BREATHER . . . . . . . . . . . . . . . 1
(Part of item 4)
Ref.
No.
Part
No.
Description
a
b
135
Qty.
Req.
907878/DP0208
Transmission
DL Series Dynalift
Control Valve Assembly Group
RIM DIAMETER
24 mm or 22 mm
Figure 1
907878/DP0208
136
PRINTED IN U.S.A.
DL Series Dynalift
Transmission
Control Valve Assembly Group
Ref.
No.
Part
No.
00
28
29
30
32
33
35
36
37
39
40
42
41
42
43
44
45c
105082
L99764
L99769
L99770
L99771
L99772
L99773
L99774
L99775
104869
L99776
L99769
L99834
L99778
NSS
L99778
L99779
NSS
105851
L99780
PRINTED IN U.S.A.
Description
Qty.
Req.
CONTROL VALVE ASSEMBLY. . . . 1
Note a
Note b
COVER SCREW . . . . . . . . . . . . . . 11
CHECK PORT PLUGS . . . . . . . . . . 2
SOL. PLATE SCREW . . . . . . . . . . . 3
BYPASS VALVE SPOOL . . . . . . . . . 1
VALVE SPRING. . . . . . . . . . . . . . . . 1
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 6
SOLENOID . . . . . . . . . . . . . . . . . . . 6
ELEC. CONTL. MODULE VALVE . . 1
Note a
Note b
CLAMP SCREW . . . . . . . . . . . . . . . 6
WIRING STRAP . . . . . . . . . . . . . . . 6
SENSOR O-RING . . . . . . . . . . . . . . 1
SPEED SENSOR (included w/#45). 1
SENSOR O-RING . . . . . . . . . . . . . . 1
JAM NUT O-RING . . . . . . . . . . . . . . 1
JAM NUT (included w/#45) . . . . . . . 1
HARNESS & SPEED SENSOR . . . 1
(Includes items 41-44.)
(24 mm rim diameter)
(22 mm rim diameter)
Ref.
No.
Part
No.
46
47
48
L99781
L99782
L99769
a
b
c
Measure the outside rim diameter of the speed
sensor (refer to Figure 1). The measurement should
either be 24 mm or 22 mm.
137
Description
Qty.
Req.
WIRING CLAMP . . . . . . . . . . . . . . . 1
CLAMP SCREW . . . . . . . . . . . . . . . 1
907878/DP0208
Axle
DL Series Dynalift
External Components Group
(26.25 and 26.28 Axles)
1
3
2
7
4
5
6
9
8
10
9
11
Driveshafts are located
in transmission section.
15
14
13
SN and Axle
Information
Plate
907878/DP0208
138
12
PRINTED IN U.S.A.
DL Series Dynalift
Axle
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
01a
L47270
L69114
01a
L71758
L69114
01a
L47270
L69114
01
L60198
L69114
01
L71723
L71577
01
L60198
L69114
02
03
04
L99951
L50253
L70582
100003
04
05
06
L70581
100008
L50836
L70715
L70970
100006
06
07
08
09
10
11
L70714
L70969
100007
L50061
L69734
L50200
L50684
L69275
L70128
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
13.00X24 TIRE SET
TIRE/13.00X24TG 12PLY . . . . . . . 4
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
13.00X24 TIRE SET (Rock)
TIRE, 13.00X24 12PLY ROCK . . . . 4
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
13.00X24 TIRE SET(Foam Filled)
TIRE/13.00X24TG 12PLY . . . . . . . 4
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
12
13
14
15
L50084
L69382
L50201
L69010
L69011
L69015
14.00X24 TIRE SET
TIRE/14.00X24TG 12PLY . . . . . . . 4
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
14.00X24 TIRE SET(Rock)
TIRE 14.00 X 24 ROCK . . . . . . . . . 4
WHEEL, 10.00VAX24 . . . . . . . . . . . 4
TIRE/14.00X24TG 12PLY . . . . . . . 4
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
a
FENDER . . . . . . . . . . . . . . . . . . . . . 4
3/8-16X3/4” BUTTON HD BOLT . . 24
FENDER MNT RF / LR (fender) . . . 2
Thru note c
Note d
FENDER MNT LF / RR (fender) . . . 2
Thru note c
Note d
3/8-16X1-3/4” BOLT . . . . . . . . . . . 16
FENDER MOUNT RF / LR (axle) . . 2
Note b
Note c
Note d
FENDER MOUNT LF / RR (axle) . . 2
Note b
Note c
Note d
3/8-16 FLARE NUT . . . . . . . . . . . . 16
M22X1.5 WHEEL NUT . . . . . . . . . 40
M20-2.5X110 MM BOLT . . . . . . . . . 8
3/4-10x11” GR8 BOLT . . . . . . . . . . . 4
LEVEL/STABILIZER MOUNT . . . . . 2
(Model DL6)
(Models DL8, DL10 and DL12)
L69016
Description
Qty.
Req.
3/4-10 NUT . . . . . . . . . . . . . . . . . . . 4
MOUNT PLATE . . . . . . . . . . . . . . . . 2
M20-2.5 CLASS 10 NUT . . . . . . . . . 8
FRONT AXLE (DL6) . . . . . . . . . . . . 1
REAR AXLE (DL6). . . . . . . . . . . . . . 1
FRONT AXLE . . . . . . . . . . . . . . . . . 1
REAR AXLE
Not available for DL10 and DL12
---- SERIAL NUMBERS ---
b
c
DL10H SN 40177 Thru SN 40399
DL10L SN 45117 Thru SN 45168
DL12H Thru SN 50158
d
DL12H SN 50159
AXLE REFERENCE TABLE
26.25 and 26.28 axles used with the following:
139
907878/DP0208
Front Axle
DL Series Dynalift
Front Axle Housing
(26.25 and 26.28 Axles)
LEFT
FRONT
30
6
38
2
14
27
3
10
2
1
11
29
9
26
26
41
40
35
34 33
31
27
28
4
32
18
26
6
20
12
13
5
15
39
4
2
16
21
2
7
22
8
36
9
37
23
17
REAR
24
19
25
Axle Serial Number
RIGHT
907878/DP0208
140
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
Front Axle Housing
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
Description
Qty.
Req.
NOTE: All quantities are per axle.
01
BEAM TRUMPET . . . . . . . . . . . . . . 1
L99461
DL6 Thru Axle SN 537
DL8/10/12 Thru Axle SN 719
L500376
DL6 Axle SN 538 Thru 1283
DL8/10/12 Axle SN 720 Thru 1695
L500608
DL6 Axle SN 1284 & Up
DL8/10/12 SN 1696 & Up
02
L99462
O-RING . . . . . . . . . . . . . . . . . . . . . . 4
03
Note a
BRAKE CYLINDER . . . . . . . . . . . . . 1
04
L500393
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
05
L99471
BUSHING . . . . . . . . . . . . . . . . . . . . 1
06
L99466
BUSHING . . . . . . . . . . . . . . . . . . . . 4
07
L99467
REAR SUPPORT . . . . . . . . . . . . . . 1
08
L99468
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
09
L99469
GREASE ZERK . . . . . . . . . . . . . . . . 2
10
L99475
THRUST WASHER . . . . . . . . . . . . . 1
11
L99474
BUSHING . . . . . . . . . . . . . . . . . . . . 1
12
L99472
BUSHING . . . . . . . . . . . . . . . . . . . . 1
13
L99473
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
14
L99465
BUSHING . . . . . . . . . . . . . . . . . . . . 1
15
L99470
THRUST WASHER . . . . . . . . . . . . . 1
16
Note a
BRAKE CYLINDER . . . . . . . . . . . . . 1
17
BEAM TRUMPET . . . . . . . . . . . . . . 1
L99477
L500376
DL8/10/12 Axle SN 720 Thru 1695
L500608
DL8/10/12 Axle SN 1696 & Up
18
L99478
BREATHER M10X1 . . . . . . . . . . . . . 1
19
L99479
BOLT . . . . . . . . . . . . . . . . . . . . . . . 24
20
L99480
BELLEVILLE WASHER . . . . . . . . . . 2
21
BUSHING . . . . . . . . . . . . . . . . . . . . 2
L99482
L500785
DL8/10/12 Axle SN 1696 & Up
22
L99483
BUSHING . . . . . . . . . . . . . . . . . . . . 2
23
OIL SEAL. . . . . . . . . . . . . . . . . . . . . 2
L99484
L500610
DL8/10/12 Axle SN 1696 & Up
24
L99485
SPHERICAL BEARING . . . . . . . . . . 2
25
L99486
26
L99615
OIL PLUG M30X2 . . . . . . . . . . . . . . 3
PRINTED IN U.S.A.
Ref.
No.
Part
No.
27
28
29
L99488
L99489
L99490
L500397
29
30
31
L99606
L500379
L99491
L99492
L500380
32
L99493
L500381
33
34
35
L99494
L99456
L99496
L500382
36
37
38
39
L500383
L500384
L500385
L99481
Description
Qty.
Req.
BREATHER, M10X1 . . . . . . . . . . . . 4
BOLT M12X110 . . . . . . . . . . . . . . . . 4
CENTRAL BODY (Model DL6) . . . . 1
CENTRAL BODY (DL8/10/12). . . . . 1
DL8/10/12 Axle SN 720 & Up
FRONT SUPPORT . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
DL6 Axle SN 537& Before
DL8/10/12 Axle SN 720 & Up
SNAP RING (not shown) . . . . . . . . . 6
DL8/10/12 Axle SN 719& Before
SCREW (shown) . . . . . . . . . . . . . . . 6
DL8/10/12 Axle SN 720 & Up
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 6
O-RING . . . . . . . . . . . . . . . . . . . . . . 6
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6
DL8/10/12 Axle SN 720 & Up
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2
DL6 Axle SN 1283 & Before
PLUG, M16X1.5. . . . . . . . . . . . . . . . 6
WASHER . . . . . . . . . . . . . . . . . . . . . 6
DL8/10/12 Axle SN 719 & Before
40
41
L500918
L99457
a
Refer to the Front Axle - Brakes section for internal
components and brake assembly part numbers.
141
907878/DP0208
Front Axle
DL Series Dynalift
Swivel Housing and Steer Cylinder
(26.25 and 26.28 Axles)
FRONT
4
5
6
LEFT
8
6 5
4
1
19
23
10
15
13
20
14
12
21
16
17
3
2
22
RIGHT
10
18
9
15
11
14
REAR
907878/DP0208
142
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
Description
Qty.
Req.
SWIVEL. HOUSING . . . . . . . . . . . . 1
01a
103008
L500617
DL8/10/12 SN 1696 & Up
02
L99498
NUT, M14. . . . . . . . . . . . . . . . . . . . . 4
02
L500266
NUT M16 . . . . . . . . . . . . . . . . . . . . . 4
DL8/10/12 Axle SN 111 & Up
03
L500265
BOLT, M14X95 . . . . . . . . . . . . . . . . 4
03
L500267
BOLT, M16X100 . . . . . . . . . . . . . . . 4
DL8/10/12 Axle SN 111 & Up
04
STEERING ARM . . . . . . . . . . . . . . 1*
L500280
DL6 only
L500281
DL8, DL10, DL12
05
L99501
NUT, M24X1.5 . . . . . . . . . . . . . . . . 1*
06
L99502
BALL JOINT . . . . . . . . . . . . . . . . . . 1*
08
L500386
STEERING CYLINDER . . . . . . . . . . 1
09
L99506
CYLINDER HEAD . . . . . . . . . . . . . . 1
10
L99507
NUT, M24X1.5 . . . . . . . . . . . . . . . . . 2
11
L500387
OIL SEAL KIT . . . . . . . . . . . . . . . . . 1
12
L99511
BUSHING . . . . . . . . . . . . . . . . . . . . 2
PRINTED IN U.S.A.
Ref.
No.
Part
No.
13
L99512
L500618
14
15
16
17a
L99513
L99514
L99515
103009
L500619
Description
Qty.
Req.
OIL SEAL . . . . . . . . . . . . . . . . . . . . 2
(Dimensions 48mmX65mmX11mm)
DL8/10/12 SN 1696 & Up
(Dimensions 48mmX65mmX16.5mm)
BOLT, M16X2X38 . . . . . . . . . . . . . 16
GREASE ZERK M6X1. . . . . . . . . . . 4
KING PIN. . . . . . . . . . . . . . . . . . . . . 2
SWIVEL. HOUSING . . . . . . . . . . . . 1
DL8/10/12 SN 1696 & Up
KING PIN. . . . . . . . . . . . . . . . . . . . . 2
BOLT, M22X55 . . . . . . . . . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
BOLT, M14X65 . . . . . . . . . . . . . . . . 2
CYLINDER ROD . . . . . . . . . . . . . . . 1
ADAP M18X1.5ORM -8JICM STR . 2
18
19
20
21
22
23
L99517
L99519
L99520
L99593
L99995
L69576
a
Must order new Item 2 (L500266) & Item 3
(L500267) when ordering new Item 1 and 17.
*
Quantity for one steering arm assembly.
143
907878/DP0208
Front Axle
DL Series Dynalift
Gear and Pinion Set
(26.25 Axle)
2
3
9
8
1
10
11
12
4
6
7
5
7
Ref.
No.
Part
No.
01
L99522
02
03
04
05
06
L99523
L99524
L99525
L99526
L99528
L99529
L99530
L99531
L99532
L99533
L99534
L99535
L99536
L99537
907878/DP0208
Description
Qty.
Req.
GEAR & PINION SET . . . . . . . . . . . 1
(Includes. Items 2-5)
LOCKWASHER . . . . . . . . . . . . . . . . 1
RING NUT, M40X1.5 . . . . . . . . . . . . 1
WASHER, 50X40X2 . . . . . . . . . . . . 2
COLLAPSIBLE SPACER. . . . . . . . . 1
SHIM, 2.50MM . . . . . . . . . . . . . . . AR
SHIM, 2.60MM . . . . . . . . . . . . . . . AR
SHIM, 2.70MM . . . . . . . . . . . . . . . AR
SHIM, 2.80MM . . . . . . . . . . . . . . . AR
SHIM, 2.90MM . . . . . . . . . . . . . . . AR
SHIM, 3.00MM . . . . . . . . . . . . . . . AR
SHIM, 3.10MM . . . . . . . . . . . . . . . AR
SHIM, 3.20MM . . . . . . . . . . . . . . . AR
SHIM, 3.30MM . . . . . . . . . . . . . . . AR
SHIM, 3.40MM . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
07
08
09
10
L99538
L99539
L99540
11
12
144
L99541
L500615
L99542
L99527
Description
Qty.
Req.
BEARING. . . . . . . . . . . . . . . . . . . . . 2
WASHER . . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
OIL SEAL 65X92X14 . . . . . . . . . . . . 1
Axle SN 1283 & Before
Axle SN 1284 & Up
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
SNAP RING D.34 . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
Gear and Pinion Set
(26.28 Axle)
2
3
10
9
1
11
12
13
4
6
7
5
8
Ref.
No.
Part
No.
01
L99612
02
03
04
05
06
L99523
L99524
L99525
L99613
L99614
L99617
L99618
L99619
L99620
L99621
L99622
L99623
L99624
L99625
PRINTED IN U.S.A.
Description
Qty.
Req.
GEAR & PINION SET . . . . . . . . . . . 1
LOCKWASHER . . . . . . . . . . . . . . . . 1
RING NUT, M40X1.5 . . . . . . . . . . . . 1
WASHER, 50X40X2 . . . . . . . . . . . . 2
SHIM, 2.50MM . . . . . . . . . . . . . . . AR
SHIM, 2.60MM . . . . . . . . . . . . . . . AR
SHIM, 2.70MM . . . . . . . . . . . . . . . AR
SHIM, 2.80MM . . . . . . . . . . . . . . . AR
SHIM, 2.90MM . . . . . . . . . . . . . . . AR
SHIM, 3.00MM . . . . . . . . . . . . . . . AR
SHIM, 3.10MM . . . . . . . . . . . . . . . AR
SHIM, 3.20MM . . . . . . . . . . . . . . . AR
SHIM, 3.30MM . . . . . . . . . . . . . . . AR
SHIM, 3.40MM . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
07
08
09
10
11
L99626
L99538
L99539
L99540
12
13
145
L99541
L500615
L99542
L99527
Description
Qty.
Req.
BEARING. . . . . . . . . . . . . . . . . . . . . 1
BEARING. . . . . . . . . . . . . . . . . . . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
OIL SEAL 65X92X14 . . . . . . . . . . . . 1
Axle SN 1749 & Up
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
SNAP RING D.34 . . . . . . . . . . . . . . 1
907878/DP0208
Front Axle
DL Series Dynalift
Axle Differential
(26.25 and 26.28 Axles)
5
6
9
7
10
8
11
8
7
3
6
5
2
4
1
Ref.
No.
Part
No.
01
L99543
L99628
02
L99544
L99629
03
L99545
L99630
04
05
06
07
L99546
L99631
L99547
L99548
L99549
907878/DP0208
Description
Qty.
Req.
DIFFERENTIAL KIT. . . . . . . . . . . . . 1
(Model DL6)
THRUST WASHER . . . . . . . . . . . . . 4
(Model DL6)
SHAFT . . . . . . . . . . . . . . . . . . . . . . . 2
(Model DL6)
DRIVE PLATE . . . . . . . . . . . . . . . . . 2
(Model DL6)
BOLT, M6X1X10 . . . . . . . . . . . . . . . 2
LOCKING PLATE . . . . . . . . . . . . . . 2
RING NUT . . . . . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
08
L99550
L99632
09
L99633
L99551
10
Description
BEARING. . . . . . . . . . . . . . . . . . . . . 2
(Model DL6)
BOLT, M12X1.75X90 . . . . . . . . . . . 10
BOLT, M10X1.5X75 . . . . . . . . . . . . 12
(Models DL6)
DIFFERENTIAL HOUSING . . . . . . . 1
(Model DL6)
PIN D12X40. . . . . . . . . . . . . . . . . . . 1
11a
L99552
L99634
L99635
a
Not used on model DL6
146
Qty.
Req.
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
Double Joint Shaft
(26.25 and 26.28 Axles)
DIFFERENTIAL SIDE
2
5
4
3
WHEEL SIDE
5
4
1
6
7
8
9
Ref.
No.
Part
No.
01
L99553
L99636
L500910
02
L99554
L99637
L500911
03
L99555
L99555
L500912
04
L99556
L99556
L500913
05
L99557
L99557
L500914
PRINTED IN U.S.A.
Description
Qty.
Req.
DOUBLE JOINT SHAFT . . . . . . . . . 2
DL6
DL8/10/12 Axle SN 1827 & Up
HALF SHAFT - DIFF. SIDE . . . . . . 1*
DL6
DL8/10/12 Axle SN 1827 & Up
CENTRAL BODY . . . . . . . . . . . . . . 1*
DL6
DL8/10/12 Axle SN 1827 & Up
SPIDER . . . . . . . . . . . . . . . . . . . . . 2*
DL6
DL8/10/12 Axle SN 1827 & Up
SNAP RING . . . . . . . . . . . . . . . . . . 8*
DL6
DL8/10/12 Axle SN 1827 & Up
Ref.
No.
Part
No.
06
07a
08
L99558
L99558
L500915
L500658
L500388
L99560
L500388
L500916
09
L99561
L99561
L500917
Description
Qty.
Req.
HALF SHAFT - WHL. SIDE . . . . . . 1*
DL6
DL8/10/12 Axle SN 1827 & Up
THRUST WASHER . . . . . . . . . . . . . 2
WASHER . . . . . . . . . . . . . . . . . . . . . 2
DL8/10/12 Axle SN 814 Thru 1826
DL8/10/12 Axle SN 1827 & Up
SNAP RING D.45 . . . . . . . . . . . . . . 2
DL6
DL8/10/12 Axle SN 1827 & Up
a
Some models used 2 washers per double joint
shaft. These have been replaced by the 1 washer
per double joint shaft shown.
*
Quantity for one double joint shaft.
147
907878/DP0208
Front Axle
DL Series Dynalift
Brakes
(26.25 and 26.28 Axles)
4
5
8
9
10
13
6
15
14
16
7
2
17
12
11
18
1
2
19
3
907878/DP0208
148
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
Brakes
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500389
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
02
L500390
O-RING . . . . . . . . . . . . . . . . . . . . . . 4
03
L99564
BRAKE PISTON, POS. . . . . . . . . . . 2
04
L99565
DRIVE PLATE . . . . . . . . . . . . . . . . . 2
05
L99566
BRAKE DISC. . . . . . . . . . . . . . . . . . 6
06
L99567
DRIVE PLATE . . . . . . . . . . . . . . . . . 6
07
L99568
SLEEVE. . . . . . . . . . . . . . . . . . . . . . 2
08
L99574
RING . . . . . . . . . . . . . . . . . . . . . . . . 2
09
L99575
SLEEVE. . . . . . . . . . . . . . . . . . . . . . 2
10
L99576
11
L99577
BRAKE PISTON, NEG. . . . . . . . . . 2
12
L500391
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
13
L99579
SNAP RING . . . . . . . . . . . . . . . . . . . 6
14
L500392
O-RING . . . . . . . . . . . . . . . . . . . . . . 6
Ref.
No.
Part
No.
15
16
17
L99581
L500393
L99996
18
19
NSS
L500295
L500759
19
L500296
L500760
PRINTED IN U.S.A.
149
Description
Qty.
Req.
SHAFT . . . . . . . . . . . . . . . . . . . . . . . 6
O-RING . . . . . . . . . . . . . . . . . . . . . . 6
SELF ADJUST KIT . . . . . . . . . . . . . 2
(3 per kit)
BRAKE CYLINDER . . . . . . . . . . . . . 1
BRAKE KIT, LH . . . . . . . . . . . . . . . . 1
(Includes items 1-3, 8-18)
DL8/10/12 Axle SN 720 & Up
BRAKE KIT, RH . . . . . . . . . . . . . . . . 1
(Includes items 1-3, 8-18)
DL8/10/12 Axle SN 720 & Up
907878/DP0208
Front Axle
DL Series Dynalift
Wheel Hub
(26.25 and 26.28 Axles)
10
4
2
1
11
4
5
6
7
3
8
9
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L99584
STUD . . . . . . . . . . . . . . . . . . . . . . . 20
02
WHEEL HUB ASY. . . . . . . . . . . . . . 2
L99585
L500640
DL8/10/12 Axle SN 1696 & Up
03
L99586
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
04
L99587
BEARING. . . . . . . . . . . . . . . . . . . . . 4
05
L99588
LOCK RING. . . . . . . . . . . . . . . . . . . 2
06
L500394
WHEEL CARRIER. . . . . . . . . . . . . . 2
07
L99590
CROWN GEAR Z=77 . . . . . . . . . . . 2
907878/DP0208
Ref.
No.
Part
No.
08
09
10
L99592
L99593
L99596
L500786
11
150
L69734
Description
Qty.
Req.
CENTERING BUSHING D20 . . . . 16
BOLT, M14X1.5X65 . . . . . . . . . . . . 16
CASSETTE SEAL 150X176X16 . . . 2
DL8/10/12 Axle SN 1696 & Up
LUG NUT. . . . . . . . . . . . . . . . . . . . 20
PRINTED IN U.S.A.
DL Series Dynalift
Front Axle
Planetary Drive
(26.25 and 26.28 Axles)
1
2
3
4
5
6
7
8
10
9
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L99597
BOLT, M10X1.25X50 . . . . . . . . . . . . 6
02
L99598
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6
03
L99599
THRUST WASHER, 60X11X3. . . . . 6
04
L99600
05
L99601
PLANETARY GEAR . . . . . . . . . . . . 6
PRINTED IN U.S.A.
Ref.
No.
Part
No.
06
07
08
09
10
L99602
L99603
L99604
L99615
L97616
151
Description
Qty.
Req.
NEEDLE BEARING-BY TENS . . . 17
THRUST WASHER, 60X40X1.5 . . . 6
PLANETARY CARRIER ASY. . . . . . 2
OIL PLUG, M30X2 . . . . . . . . . . . . . . 2
BOLT, M8X20 . . . . . . . . . . . . . . . . . 4
907878/DP0208
Rear Axle
DL Series Dynalift
Rear Axle Housing
(26.25 and 26.28 Axles)
RIGHT
REAR
29
6
31
5
2
3
15
2
1
14
28
9
26
26
30
27
4
18
26
6
20
12
13
11
10
4
34
2
16
21
2
7
22
8
32
9
33
23
17
FRONT
24
19
25
Axle Serial Number
LEFT
907878/DP0208
152
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Rear Axle Housing
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
01
L99461
L500376
L500608
02
03a
L99462
L99641
L500395
04
05
06
07
08
09
10
11
12
13
14
15
16a
L500393
L99465
L99466
L99467
L99468
L99469
L99470
L99471
L99472
L99473
L99474
L99475
L99642
L500396
17
L99477
L500376
L500608
18
19
L99478
L99479
PRINTED IN U.S.A.
Description
Qty.
Req.
BEAM TRUMPET . . . . . . . . . . . . . . 1
DL8/10/12 Axle SN 612 Thru 1612
DL8/10/12 SN 1613 & Up
O-RING . . . . . . . . . . . . . . . . . . . . . . 4
BRAKE CYLINDER . . . . . . . . . . . . . 1
DL8/10/12 Axle SN 612 & Up
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 4
SUPPORT FRONT . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
GREASE ZERK . . . . . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
THRUST WASHER . . . . . . . . . . . . . 1
BRAKE CYLINDER . . . . . . . . . . . . . 1
DL8/10/12 Axle SN 612 & Up
BEAM TRUMPET . . . . . . . . . . . . . . 1
DL6 Axle SN 537 Thru SN 1434
DL8/10/12 Axle SN 612 Thru 1612
DL8/10/12 SN 1613 & Up
BREATHER M10X1 . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . 24
Ref.
No.
Part
No.
20
21
L99480
L99482
L500785
22
23
L99483
L99484
L500610
24
25
26
27
28
L99485
L99486
L99615
L99489
L99490
L500397
28
29
30
L99606
L500379
L99491
L99492
L500380
31
32
33
34
L500385
L500383
L500384
L99481
Description
Qty.
Req.
BUSHING . . . . . . . . . . . . . . . . . . . . 2
DL8/10/12 Axle SN 1613 & Up
BUSHING . . . . . . . . . . . . . . . . . . . . 2
OIL SEAL. . . . . . . . . . . . . . . . . . . . . 2
DL8/10/12 Axle SN 1613 & Up
OIL PLUG M30X2 . . . . . . . . . . . . . . 3
BOLT M12X110 . . . . . . . . . . . . . . . . 4
CENTRAL BODY (DL6). . . . . . . . . . 1
CENTRAL BODY (DL8/10/12). . . . . 1
DL8/10/12 Axle SN 612 & Up
SUPPORT . . . . . . . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
DL8/10/12 Axle SN 612 & Up
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2
SHIM . . . . . . . . . . . . . . . . . . . . . . . . 2
a
Does not include internal brake components. This
machine is not equipped with brakes on the rear axle.
153
907878/DP0208
Rear Axle
DL Series Dynalift
Axle Swivel Housings and Steer Cylinder
(26.25 and 26.28 Axles)
REAR
RIGHT
16
1
2
17
15
14
18
3
19
4
5
6
8
10
6
5
20
4
17
21
16
25
22
23
9
10
24
13
11
12
LEFT
FRONT
907878/DP0208
154
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Axle Swivel Housings and Steer Cylinder
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
01a
103008
L500617
02
L99498
02
L500266
03
L500265
03
L500267
04
05
06
08
09
10
11
12
13
L500280
L500281
L99501
L99502
L99504
L99506
L99507
L99610
L99509
L500387
PRINTED IN U.S.A.
Description
Qty.
Req.
SWIVEL. HOUSING . . . . . . . . . . . . 1
DL8/10/12 SN 1613 & Up
NUT, M14. . . . . . . . . . . . . . . . . . . . . 4
NUT, M16. . . . . . . . . . . . . . . . . . . . . 4
DL8/10/12 Axle SN 136 & Up
BOLT, M14X95 . . . . . . . . . . . . . . . . 4
DL8/10/12 Axle SN135 & Before
BOLT, M16X100 . . . . . . . . . . . . . . . 4
DL8/10/12 Axle SN 136 & Up
STEERING ARM . . . . . . . . . . . . . . 1*
DL6 only
DL8, DL10, DL12
NUT, M24X1.5 . . . . . . . . . . . . . . . . 1*
BALL JOINT . . . . . . . . . . . . . . . . . . 1*
CYLINDER HEAD . . . . . . . . . . . . . . 2
NUT, M24X1.5 . . . . . . . . . . . . . . . . . 2
STEERING SENSOR . . . . . . . . . . . 1
CLAMP . . . . . . . . . . . . . . . . . . . . . . 2
CYLINDER SEAL KIT (seals only) . 1
Ref.
No.
Part
No.
14
15
L99511
L99512
L500618
16
17
18
19a
L99513
L99514
L99515
103009
L500619
Description
Qty.
Req.
BUSHING . . . . . . . . . . . . . . . . . . . . 2
OIL SEAL 48X65X11 . . . . . . . . . . . . 2
(Dimensions 48mmX65mmX11mm)
DL8/10/12 SN 1613 & Up
(Dimensions 48mmX65mmX16.5mm)
BOLT, M16X2X38 . . . . . . . . . . . . . 16
GREASE ZERK M6X1. . . . . . . . . . . 4
KING PIN. . . . . . . . . . . . . . . . . . . . . 2
SWIVEL. HOUSING . . . . . . . . . . . . 1
DL8/10/12 SN 1613 & Up
KING PIN. . . . . . . . . . . . . . . . . . . . . 2
BOLT, M22X55 . . . . . . . . . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
BOLT, M14X65 . . . . . . . . . . . . . . . . 2
ROD. . . . . . . . . . . . . . . . . . . . . . . . . 1
ADAP M18X1.5ORM -8JICM STR . 2
20
21
22
23
24
25
L99517
L99519
L99520
L99593
L99995
L69576
a
Must order new Item 2 (L500266) & Item 3
(L500267) when ordering new Item 1.
*
Quantity for one steering arm assembly.
155
907878/DP0208
Rear Axle
DL Series Dynalift
Axle Gear and Pinion Set
(26.25 Axle)
2
3
9
8
1
10
11
12
4
6
7
5
7
Ref.
No.
Part
No.
01
L99643
02
03
04
05
06
L99523
L99524
L99525
L99526
L99528
L99529
L99530
L99531
L99532
L99533
L99534
L99535
L99536
L99537
907878/DP0208
Description
Qty.
Req.
GEAR & PINION SET . . . . . . . . . . . 1
(Includes Items 2-4)
LOCKWASHER . . . . . . . . . . . . . . . . 1
RING NUT, M40X1.5 . . . . . . . . . . . . 1
WASHER, 50X40X2 . . . . . . . . . . . . 2
SHIM, 2.50MM . . . . . . . . . . . . . . . AR
SHIM, 2.60MM . . . . . . . . . . . . . . . AR
SHIM, 2.70MM . . . . . . . . . . . . . . . AR
SHIM, 2.80MM . . . . . . . . . . . . . . . AR
SHIM, 2.90MM . . . . . . . . . . . . . . . AR
SHIM, 3.00MM . . . . . . . . . . . . . . . AR
SHIM, 3.10MM . . . . . . . . . . . . . . . AR
SHIM, 3.20MM . . . . . . . . . . . . . . . AR
SHIM, 3.30MM . . . . . . . . . . . . . . . AR
SHIM, 3.40MM . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
07
08
09
10
L99538
L99539
L99540
11
12
156
L99541
L500615
L99542
L99527
Description
Qty.
Req.
BEARING. . . . . . . . . . . . . . . . . . . . . 2
WASHER . . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
OIL SEAL 65X92X14 . . . . . . . . . . . . 1
Axle SN 1435 & Up
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
SNAP RING D.34 . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Gear and Pinion Set
(26.28 Axle)
2
3
10
9
1
11
12
13
4
6
7
5
8
Ref.
No.
Part
No.
01
L99649
02
03
04
05
06
L99523
L99524
L99525
L99613
L99614
L99617
L99618
L99619
L99620
L99621
L99622
L99623
L99624
L99625
PRINTED IN U.S.A.
Description
Qty.
Req.
GEAR & PINION SET . . . . . . . . . . . 1
LOCKWASHER . . . . . . . . . . . . . . . . 1
RING NUT, M40X1.5 . . . . . . . . . . . . 1
WASHER, 50X40X2 . . . . . . . . . . . . 2
SHIM, 2.50MM . . . . . . . . . . . . . . . AR
SHIM, 2.60MM . . . . . . . . . . . . . . . AR
SHIM, 2.70MM . . . . . . . . . . . . . . . AR
SHIM, 2.80MM . . . . . . . . . . . . . . . AR
SHIM, 2.90MM . . . . . . . . . . . . . . . AR
SHIM, 3.00MM . . . . . . . . . . . . . . . AR
SHIM, 3.10MM . . . . . . . . . . . . . . . AR
SHIM, 3.20MM . . . . . . . . . . . . . . . AR
SHIM, 3.30MM . . . . . . . . . . . . . . . AR
SHIM, 3.40MM . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
07
08
09
10
11
L99626
L99538
L99539
L99540
12
13
157
L99541
L500615
L99542
L99527
Description
Qty.
Req.
BEARING. . . . . . . . . . . . . . . . . . . . . 1
BEARING. . . . . . . . . . . . . . . . . . . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
OIL SEAL 65X92X14 . . . . . . . . . . . . 1
Thru Axle SN 1612
Axle SN 1613 & Up
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
SNAP RING D.34 . . . . . . . . . . . . . . 1
907878/DP0208
Rear Axle
DL Series Dynalift
Axle Differential
(26.25 and 26.28 Axles)
5
6
9
7
10
8
11
8
7
5
3
6
2
4
Ref.
No.
Part
No.
01
L99543
L99628
02
L99544
L99629
03
L99545
L99630
04
05
06
L99546
L99631
L99547
L99548
907878/DP0208
Description
Qty.
Req.
(Model DL6)
(Models DL8/10/12)
THRUST WASHER . . . . . . . . . . . . . 4
(Model DL6)
(Models DL/8/10/12)
SHAFT . . . . . . . . . . . . . . . . . . . . . . . 2
(Model DL/6)
(Models DL/8/10/12)
DRIVE PLATE . . . . . . . . . . . . . . . . . 2
(Model DL6)
(Models DL8/10/12)
BOLT, M6X1X10 . . . . . . . . . . . . . . . 2
LOCKING PLATE . . . . . . . . . . . . . . 2
1
Ref.
No.
Part
No.
07
08
L99549
L99550
L99632
09
L99551
L99633
10
Description
RING NUT . . . . . . . . . . . . . . . . . . . . 2
BEARING. . . . . . . . . . . . . . . . . . . . . 2
(Model DL6)
(Models DL8/10/12)
BOLT, M10X1.5X75 (Model DL6) . 12
BOLT, M12X1.75X90 . . . . . . . . . . . 10
(Models DL8/10/12)
(Model DL6)
(Models DL8/10/12)
PIN D12X40. . . . . . . . . . . . . . . . . . . 1
11a
L99552
L99634
L99635
a
Not used on model DL6
158
Qty.
Req.
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Axle Double Joint Shaft
(26.25 and 26.28 Axles)
DIFFERENTIAL SIDE
2
5
4
3
WHEEL SIDE
5
4
1
6
7
8
9
Ref.
No.
Part
No.
01
L99553
L99636
L500910
02
L99554
L99637
L500911
03
L99555
L99555
L500912
04
L99556
L99556
L500913
05
L99557
L99557
L500914
PRINTED IN U.S.A.
Description
Qty.
Req.
DOUBLE JOINT SHAFT . . . . . . . . . 2
DL6
DL8/10/12 Axle SN 1717 and Up
HALF SHAFT - DIFF. SIDE . . . . . . 1*
DL6
DL8/10/12 Axle SN 1717 and Up
CENTRAL BODY . . . . . . . . . . . . . . 1*
DL6
DL8/10/12 Axle SN 1717 & Up
SPIDER . . . . . . . . . . . . . . . . . . . . . 2*
DL6
DL8/10/12 Axle SN 1717 & Up
SNAP RING . . . . . . . . . . . . . . . . . . 8*
DL6
DL8/10/12 Axle SN 1717 & Up
Ref.
No.
Part
No.
06
07a
08
L99558
L99558
L500915
L500658
L500388
L99560
L500388
L500916
09
L99561
L99561
L500917
Description
Qty.
Req.
HALF SHAFT - WHL. SIDE . . . . . . 1*
DL6
DL8/10/12 Axle SN 1717 & Up
THRUST WASHER . . . . . . . . . . . . . 2
WASHER . . . . . . . . . . . . . . . . . . . . . 2
DL8/10/12 Axle 832 & Before
DL8/10/12 Axle SN 833 Thru 1716
DL8/10/12 Axle SN 1717 & Up
SNAP RING D.45 . . . . . . . . . . . . . . 2
DL6
DL8/10/12 Axle SN 1717 & Up
a
Some models used 2 washers per double joint
shaft. These have been replaced by the 1 washer
per double joint shaft shown.
*
Quantity for one double joint shaft.
159
907878/DP0208
Rear Axle
DL Series Dynalift
Axle Wheel Hub
(26.25 and 26.28 Axles)
2
1
11
10
4
6
7
3
4
5
8
9
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L99584
STUD . . . . . . . . . . . . . . . . . . . . . . . 20
02
WHEEL HUB ASY. . . . . . . . . . . . . . 2
L99585
L500640
DL8/10/12 Axle SN 1613 & Up
03
L99586
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
04
L99587
BEARING. . . . . . . . . . . . . . . . . . . . . 4
05
L99588
LOCK RING. . . . . . . . . . . . . . . . . . . 2
06
WHEEL CARRIER. . . . . . . . . . . . . . 2
L99589
L500394
DL8/10/12 Axle SN 783 & Up
907878/DP0208
Ref.
No.
Part
No.
07
08
09
10
L99590
L99592
L99593
L99596
L500786
11
160
L69734
Description
Qty.
Req.
CROWN GEAR Z=77 . . . . . . . . . . . 2
CENTERING BUSHING D20 . . . . 16
BOLT, M14X1.5X65 . . . . . . . . . . . . 16
CASSETTE SEAL 150X176X16 . . . 2
DL8/10/12 Axle SN 1613 & Up
LUG NUT . . . . . . . . . . . . . . . . . . . 20
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Axle Planetary Drive
(26.25 and 26.28 Axles)
1
2
3
4
5
6
7
8
9
Ref.
No.
Part
No.
Description
10
Qty.
Req.
01
L99597
BOLT, M10X1.25X50 . . . . . . . . . . . . 6
02
L99598
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6
03
L99599
04
L99600
05
L99601
PLANETARY GEAR . . . . . . . . . . . . 6
PRINTED IN U.S.A.
Ref.
No.
Part
No.
06
07
08
09
10
L99602
L99603
L99604
L99615
L97616
161
Description
Qty.
Req.
NEEDLE BEARING-BY TENS . . . 17
THRUST WASHER, 60X40X1.5 . . . 6
PLANETARY CARRIER ASY. . . . . . 2
OIL PLUG, M30X2 . . . . . . . . . . . . . . 2
BOLT, M8X20 . . . . . . . . . . . . . . . . . 4
907878/DP0208
Front and Rear Axle
DL Series Dynalift
(26.48 Axle)
13
3
4
Driveshafts are located
in transmission section.
7
6
2
5
11
9
8
10
12
1
907878/DP0208
162
PRINTED IN U.S.A.
DL Series Dynalift
Front and Rear Axle
(26.48 Axle)
Ref.
No.
Part
No.
Description
Qty.
Req.
13.00X24 TIRE SET
01a
L47270
TIRE/13.00X24TG 12PLY . . . . . . . 4
L69114
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
13.00X24 TIRE SET (Rock)
01a
L71758
TIRE, 13.00X24 12PLY ROCK . . . . 4
L69114
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
01a
L47270
TIRE/13.00X24TG 12PLY . . . . . . . 4
L69114
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
01
14.00X24 TIRE SET
L60198
TIRE/14.00X24TG 12PLY . . . . . . . 4
L69114
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
01
14.00X24 TIRE SET(Rock)
L71723
TIRE 14.00 X 24 ROCK . . . . . . . . . 4
L71577
WHEEL, 10.00VAX24 . . . . . . . . . . 4
01
L60198
TIRE/14.00X24TG 12PLY . . . . . . . 4
L69114
WHEEL/24 X 9.00 GR . . . . . . . . . . 4
02
L99951
FENDER . . . . . . . . . . . . . . . . . . . . . 4
03
L50253
3/8-16X3/4” BUTTON HD BOLT . . 12
Ref.
No.
Part
No.
04
05
06
07
08
09
10
11
12
13
100003
100008
L50836
100260
100259
656052
L69734
100252
100255
L50684
L50084
100330
100332
a
Description
Qty.
Req.
FENDER MOUNT (fender)
(Right Front / Left Rear) . . . . . . . . . 2
(Left Front / Right Rear) . . . . . . . . . 2
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 8
FENDER MOUNT (axle) . . . . . . . . . 2
(Right Front / Left Rear) . . . . . . . . . 2
(Left Front / Right Rear) . . . . . . . . . 2
M16-2.00 NUT . . . . . . . . . . . . . . . . . 8
M22X1.5 WHEEL NUT . . . . . . . . . 20
LEVEL/STABILIZER PLATE . . . . . . 1
3/4-10X11 BOLT . . . . . . . . . . . . . . . 4
3/4-10 NUT . . . . . . . . . . . . . . . . . . . 4
AXLE
FRONT . . . . . . . . . . . . . . . . . . . . . . 1
REAR. . . . . . . . . . . . . . . . . . . . . . . . 1
Not available for models DL10 and DL12
PRINTED IN U.S.A.
163
907878/DP0208
Front and Rear Axle
DL Series Dynalift
Axle Housing
(26.48 Axle)
1
8
36
2
41
35
34
32
3
4
5
30
31
42
6
33
3
2
37
7
28
5
29
8
9
21
27
6
38
15
37
26
16 17
18
13 14
25
19
12
10
40
20
11
22
39
24
23
43
907878/DP0208
164
PRINTED IN U.S.A.
DL Series Dynalift
Front and Rear Axle
Axle Housing
(26.48 Axle)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500787
LEG HOUSING . . . . . . . . . . . . . . . . 1
(Left Front Axle, Right Rear Axle)
02
L99615
PLUG M30x2 . . . . . . . . . . . . . . . . . . 2
03
L99488
BREATHER M10x1 . . . . . . . . . . . . . 2
04
102324
BRAKE CYLINDER . . . . . . . . . . . . . 1
05
L500789
PLUG M24x1.5 . . . . . . . . . . . . . . . . 2
06
L500790
PIN D16x40 . . . . . . . . . . . . . . . . . . . 4
07
L500791
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 6
08
L99466
BUSHING . . . . . . . . . . . . . . . . . . . . 4
09
L500792
SUPPORT . . . . . . . . . . . . . . . . . . . . 1
(Rear Front Axle, Front Rear Axle)
10
L500793
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
11
L99514
ZERK/GREASE M6x1 . . . . . . . . . . . 1
12
L500794
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
13
L500795
BUSHING . . . . . . . . . . . . . . . . . . . . 1
14
L500796
BUSHING . . . . . . . . . . . . . . . . . . . . 1
15
L500797
THRUST WASHER . . . . . . . . . . . . . 1
16
L500798
RING . . . . . . . . . . . . . . . . . . . . . . . . 1
17
L500799
CENTRAL BODY. . . . . . . . . . . . . . . 1
18
102323
BRAKE CYLINDER . . . . . . . . . . . . . 1
(Right Front Axle, Left Rear Axle)
19
L500801
BOLT M16x65 . . . . . . . . . . . . . . . . . 4
20
L500802
BOLT M16x160 . . . . . . . . . . . . . . . 26
21
L500803
LEG HOUSING . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
L500804
L500805
L500618
L99511
L500806
L500807
L99478
L500808
L500809
L500810
L99471
L500811
L500812
L99469
L500813
37
38
L500814
L500815
39
L500816
40
L500817
41
42
43
651599
L50201
101308
Description
Qty.
Req.
SEAL RING . . . . . . . . . . . . . . . . . . . 2
BEARING. . . . . . . . . . . . . . . . . . . . . 2
SEAL RING . . . . . . . . . . . . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
BEARING. . . . . . . . . . . . . . . . . . . . . 2
SEAL RING . . . . . . . . . . . . . . . . . . . 2
BREATHER M10x1 . . . . . . . . . . . . . 1
BREATHER EXTENSION . . . . . . . . 1
SEAL RING . . . . . . . . . . . . . . . . . . . 1
THRUST WASHER . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
ZERK/GREASE M8x1 . . . . . . . . . . . 1
SUPPORT . . . . . . . . . . . . . . . . . . . . 1
(Front Front Axle, Rear Rear Axle)
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2
PIN D10x25 . . . . . . . . . . . . . . . . . . 1
(Front Axle Only)
BRAKE CALIPER SUPPORT . . . . . 1
(Front Axle Only)
BOLT M10x35 . . . . . . . . . . . . . . . . . 6
(Front Axle Only)
M20-2.50X150 BOLT . . . . . . . . . . . . 4
NUT, M20-2.5 . . . . . . . . . . . . . . . . . 4
BRAKE CALIPER ASY . . . . . . . . . . 1
(Front Axle Only)
(See Hydraulic Component Section
for more parts)
PRINTED IN U.S.A.
165
907878/DP0208
Front and Rear Axle
DL Series Dynalift
(26.48 Axle)
16
13
15
14
17
18
8
14
13
19
15
16
1
9
7
10
21
2
7
8
11
24
20
25
3
26
8
9
4
22
12
20
24
5
23
8
10
6
907878/DP0208
166
PRINTED IN U.S.A.
DL Series Dynalift
Front and Rear Axle
(26.48 Axle)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500818
SPECIAL BOLT M16x38 . . . . . . . . . 8
02
L500819
UPPER KIN PIN . . . . . . . . . . . . . . . 2
03
SHIM. . . . . . . . . . . . . . . . . . . . . . . AR
103483
0.15mm . . . . . . . . . . . . . . . . . . . . . . .
103484
0.20mm
103485
0.50mm
04
103486
SWIVEL HOUSING . . . . . . . . . . . . . 1
05
L500822
LOWER KING PIN. . . . . . . . . . . . . . 2
06
L99513
BOLT M16x38 . . . . . . . . . . . . . . . . . 8
07
L500823
BOLT M16x130 . . . . . . . . . . . . . . . . 2
08
L500266
NUT M16 . . . . . . . . . . . . . . . . . . . . . 4
09
L500824
BUSHING . . . . . . . . . . . . . . . . . . . . 2
10
L500825
NUT M27x1.5 . . . . . . . . . . . . . . . . . 2
11
L500826
SEAL RING . . . . . . . . . . . . . . . . . . . 2
12
L500827
BUSHING . . . . . . . . . . . . . . . . . . . . 2
13
L500828
STEERING ARM ASY . . . . . . . . . . . 2
PRINTED IN U.S.A.
Ref.
No.
Part
No.
14
15
16
17
18
L500829
L500830
L500831
L500832
19
20
21
22
23
24
25
26
167
L500833
L500905
103487
L500267
L99506
L500835
L500836
L500906
L500837
L99561
L99610
Description
Qty.
Req.
BALL JOINT. . . . . . . . . . . . . . . . . . . 2
NUT M28x1.5 . . . . . . . . . . . . . . . . . 2
TIE ROD . . . . . . . . . . . . . . . . . . . . . 2
BOLT M16x45 . . . . . . . . . . . . . . . . . 3
Front Axle
Rear Axle
SWIVEL HOUSING . . . . . . . . . . . . . 1
BOLT M16x100 . . . . . . . . . . . . . . . . 2
CYLINDER HEAD . . . . . . . . . . . . . . 1
ROD. . . . . . . . . . . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
Front Axle
Rear Axle
BUSHING . . . . . . . . . . . . . . . . . . . . 2
CLAMP (Rear Axle Only). . . . . . . . . 2
SENSOR (Rear Axle Only) . . . . . . . 1
907878/DP0208
Front Axle
DL Series Dynalift
Gear and Pinion Set
(26.48 Axle)
7
8
9
10
11
2
3
2
1
4
5
6
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L500838
L500839
L500840
L500841
L500842
L500843
L500844
L500845
L500846
L500847
907878/DP0208
Description
Qty.
Req.
BEVEL GEAR / PINION Z10/36 . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 1
NUT M30x2 . . . . . . . . . . . . . . . . . . . 1
SHIM 2.5mm. . . . . . . . . . . . . . . . . AR
SHIM 2.6mm. . . . . . . . . . . . . . . . . AR
SHIM2.7mm . . . . . . . . . . . . . . . . . AR
SHIM 2.8mm. . . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
08
09
10
11
L500848
L500849
L500850
L500851
L500852
L500853
L500854
L500855
L500856
L500857
168
Description
Qty.
Req.
SHIM 2.9mm. . . . . . . . . . . . . . . . . AR
SHIM 3.0mm. . . . . . . . . . . . . . . . . AR
SHIM 3.1mm. . . . . . . . . . . . . . . . . AR
SHIM 3.2mm. . . . . . . . . . . . . . . . . AR
SHIM 3.3mm. . . . . . . . . . . . . . . . . AR
SHIM 3.4mm. . . . . . . . . . . . . . . . . AR
BEARING. . . . . . . . . . . . . . . . . . . . . 1
BEARING. . . . . . . . . . . . . . . . . . . . . 1
SEAL RING . . . . . . . . . . . . . . . . . . . 1
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Rear Axle
Gear and Pinion Set
(26.48 Axle)
7
8
9
10
11
12
2
3
2
1
4
5
6
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L500907
L500839
L500840
L500841
L500842
L500843
L500844
L500845
L500846
L500847
PRINTED IN U.S.A.
Description
Qty.
Req.
BEVEL GEAR / PINION Z10/36 . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . . 1
WASHER . . . . . . . . . . . . . . . . . . . . . 1
NUT M30x2 . . . . . . . . . . . . . . . . . . . 1
SHIM 2.5mm. . . . . . . . . . . . . . . . . AR
SHIM 2.6mm. . . . . . . . . . . . . . . . . AR
SHIM2.7mm . . . . . . . . . . . . . . . . . AR
SHIM 2.8mm. . . . . . . . . . . . . . . . . AR
Ref.
No.
Part
No.
08
09
10
11
12
L500848
L500849
L500850
L500851
L500852
L500853
L500854
L500855
L500856
L500908
L500909
169
Description
Qty.
Req.
SHIM 2.9mm. . . . . . . . . . . . . . . . . AR
SHIM 3.0mm. . . . . . . . . . . . . . . . . AR
SHIM 3.1mm. . . . . . . . . . . . . . . . . AR
SHIM 3.2mm. . . . . . . . . . . . . . . . . AR
SHIM 3.3mm. . . . . . . . . . . . . . . . . AR
SHIM 3.4mm. . . . . . . . . . . . . . . . . AR
BEARING. . . . . . . . . . . . . . . . . . . . . 1
BEARING. . . . . . . . . . . . . . . . . . . . . 1
SEAL RING . . . . . . . . . . . . . . . . . . . 1
PROTECTING COVER . . . . . . . . . . 1
FLANGE . . . . . . . . . . . . . . . . . . . . . 1
907878/DP0208
Front and Rear Axle
DL Series Dynalift
Differential
(26.48 Axle)
11
10
12
13
5
2
9
3
1
8
4
7
5
6
2
7
8
9
11
Ref.
No.
10
Part
No.
Description
Qty.
Req.
01
L500858
02
L500859
THRUST WASHER . . . . . . . . . . . . . 2
03
L500860
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1
04
L500861
PIN D7x124 . . . . . . . . . . . . . . . . . . . 1
05
L500862
COUNTER DISC . . . . . . . . . . . . . . . 2
06
L500863
907878/DP0208
Ref.
No.
Part
No.
07
08
09
10
11
12
13
L500864
L500865
L500866
L500867
L99547
L500868
L500869
170
Description
Qty.
Req.
BUSH. . . . . . . . . . . . . . . . . . . . . . . . 2
BEARING. . . . . . . . . . . . . . . . . . . . . 2
RING NUT . . . . . . . . . . . . . . . . . . . . 2
LOCKING PLATE . . . . . . . . . . . . . . 2
BOLT M6x10 . . . . . . . . . . . . . . . . . . 2
BOLT . . . . . . . . . . . . . . . . . . . . . . . 12
DIFF. HOUSING COVER . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Front and Rear Axle
Double U-Joint
(26.48 Axle)
2
3
1
5
4
6
7
8
9
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500870
DOUBLE JOINT . . . . . . . . . . . . . . . 2
02
L500871
FORK (Diff. Side). . . . . . . . . . . . . . . 2
03
L500872
CENTRAL BODY. . . . . . . . . . . . . . . 2
04
L500873
SPIDER . . . . . . . . . . . . . . . . . . . . . . 4
PRINTED IN U.S.A.
Ref.
No.
Part
No.
05
06
07
08
09
L500874
L500875
L500876
L500877
L500878
171
Description
Qty.
Req.
LOCK RING. . . . . . . . . . . . . . . . . . 16
FORK (Wheel Side). . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 2
WASHER . . . . . . . . . . . . . . . . . . . . . 2
LOCK RING. . . . . . . . . . . . . . . . . . . 2
907878/DP0208
Front and Rear Axle
DL Series Dynalift
Wheel Hub and Final Reduction
(26.48 Axle)
1
2
3
5
4
6
2
7
8
9
21
20
19
17 18
11
10
15
16
18 17
12
14
13
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500786
SEAL RING . . . . . . . . . . . . . . . . . . . 2
02
L500889
BEARING. . . . . . . . . . . . . . . . . . . . . 4
03
L500890
SPACER . . . . . . . . . . . . . . . . . . . . . 2
04
L500891
WHEEL HUB KIT. . . . . . . . . . . . . . . 2
05
L99584
STUD . . . . . . . . . . . . . . . . . . . . . . . 20
06
L99586
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
07
L500892
LOCK RING. . . . . . . . . . . . . . . . . . . 2
08
L500893
WHEEL CARRIER. . . . . . . . . . . . . . 2
09
L500894
RING NUT M90x2 . . . . . . . . . . . . . . 2
10
L500895
BOLT M10x12 . . . . . . . . . . . . . . . . . 6
907878/DP0208
Ref.
No.
Part
No.
11
12
13
14
15
16
17
18
19
20
21
L500896
L99615
L97616
L500897
L500898
L500899
L500900
L500901
L500902
L500903
L500904
172
Description
Qty.
Req.
LOCKING PLATE . . . . . . . . . . . . . . 2
PLUG M30x2 . . . . . . . . . . . . . . . . . . 2
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 4
PLANETARY CARRIER ASY . . . . . 2
GEAR Z=31 . . . . . . . . . . . . . . . . . . . 6
BEARING. . . . . . . . . . . . . . . . . . . . . 6
THRUST WASHER . . . . . . . . . . . . 12
SNAP RING D72 . . . . . . . . . . . . . . 12
SNAP RING D50 . . . . . . . . . . . . . . . 6
THRUST WASHER . . . . . . . . . . . . . 6
CROWN GEAR Z=81 . . . . . . . . . . . 2
PRINTED IN U.S.A.
DL Series Dynalift
Front and Rear Axle
Brakes
(26.48 Axle)
9
1
2
3
4
5
8
7
6
5
6
5
Ref.
No.
Part
No.
Description
Qty.
Req.
01
L500879
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
02
L500880
O-RING . . . . . . . . . . . . . . . . . . . . . . 2
03
L500881
BRAKE PISTON . . . . . . . . . . . . . . . 2
04
L500882
SELF-ADJUST KIT . . . . . . . . . . . . . 2
PRINTED IN U.S.A.
Ref.
No.
Part
No.
05
06
07
08
09
L500883
L500884
L500885
L500886
L500887
173
Description
Qty.
Req.
BRAKE COUNTER DISK . . . . . . . . 6
BRAKE DISC. . . . . . . . . . . . . . . . . . 4
SNAP RING D150 . . . . . . . . . . . . . . 2
HUB . . . . . . . . . . . . . . . . . . . . . . . . . 2
SELF-ADJUST KIT . . . . . . . . . . . . . 2
907878/DP0208
Three-Section Low Boom
DL Series Dynalift
Outer Boom - Rear Section
1
3
4
2
6
5
6
10
5
7
9
8
19
14
15
12
13
12
11
11
16
18
17
14
907878/DP0208
174
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L50463
L520019
L69474
L10465
L530004
L50230
L69866
L50056
L510008
Note a
L50608
PRINTED IN U.S.A.
Description
Qty.
Req.
1/2-13X6” BOLT. . . . . . . . . . . . . . . . 1
BOOM PIVOT PIN. . . . . . . . . . . . . . 1
ZERK 1/4-28 STRAIGHT. . . . . . . . . 2
5/16” CLIP RETAINING NUT. . . . . 11
5/16-18X3/4” BOLT . . . . . . . . . . . . 11
REAR BOOM COVER. . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 5
5/16-18X5/8” BOLT . . . . . . . . . . . . . 5
BOOM SIDE COVER . . . . . . . . . . . 1
3/16X4” COTTER PIN . . . . . . . . . . . 2
Ref.
No.
Part
No.
12
13
14
15
16
17
18
19
L400207
L69994
L50519
L69480
L50956
L70420
L71527
L69492
a
40’ Low Boom, use PN L69867
175
Description
Qty.
Req.
THRUST WASHER . . . . . . . . . . . . . 2
EXTEND CYL. PIN (BASE END) . . 1
EXTEND MOUNT WELDMENT . . . 1
3/4-10X2-1/2” BOLT . . . . . . . . . . . . 8
TRUNNION SHIM . . . . . . . . . . . . . . 1
BUSHING (Ext. cyl. base end) . . . . 1
BUSHING, PIVOT PIN. . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Outer Boom - Front Section
26
13
27
25
31
32
28
24
16
18
16
17 18
1
30
29
23
22
2
21
3
4
16
5
16
20
18
19
17
15
9
13
19
17
10
14
12
33
34
907878/DP0208
8
7
6
11
Low Boom
models only
176
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
Part
No.
Note a
L70242
L65640
L50141
L52048
L50491
L50136
L65638
L520004
L50061
L52026
L70639
L70040
L70462
L520005
L50835
L62733
L50251
L50147
L62715
L61708
L61709
PRINTED IN U.S.A.
Description
Qty.
Req.
OUTER BOOM WELDMENT . . . . . 1
5/16-18 NUT INSERT . . . . . . . . . . . 2
BOOM ANGLE IND. PLATE . . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . . 2
5/16-18X1” BUTTON HD BOLT. . . . 2
#8X5/8” RND HD MACH SCREW. . 2
#10 LOCK WASHER . . . . . . . . . . . . 2
INCLINOMETER - ANGLE IND. . . . 1
3/8-16 FLARE NUT . . . . . . . . . . . . . 2
3/8-16X1-1/4” BOLT . . . . . . . . . . . . 4
BOOM LIGHT BRACKET (LH) . . . . 1
WORK LIGHT . . . . . . . . . . . . . . . . . 2
LIGHT HARNESS (not shown). . . . 1
5/16-18X2” BOLT. . . . . . . . . . . . . . . 2
1/16”X3X4 SHIM . . . . . . . . . . . . . . . 6
3/8-16X3/4” BOLT . . . . . . . . . . . . . 16
3/8” LOCK WASHER . . . . . . . . . . . 12
FLAT-BOLT LOCK . . . . . . . . . . . . . . 4
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
Ref.
No.
Part
No.
22
23
24
25
26
L64143
L64132
L50836
L70635
L64359
27
28
29
30
31
32
33
34
L50380
L560003
L64384
L64468
L50152
Note b
L70429
L50403
a
b
177
Description
Qty.
Req.
1/2”X3X4 SHIM . . . . . . . . . . . . . . . . 2
3/8” PAD SPACER. . . . . . . . . . . . . . 2
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 4
BOOM LIGHT BRACKET (RH) . . . . 1
ADJUSTABLE CLEVIS PIN. . . . . . . 3
(does not include nuts or cotter pins)
1/2-20X1-1/4” GRD 8 BOLT . . . . . . 3
3/32X1-1/4” COTTER PIN . . . . . . . . 2
CLEVIS . . . . . . . . . . . . . . . . . . . . . . 1
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
1/2” LOCK WASHER . . . . . . . . . . . . 3
LEAF CHAIN . . . . . . . . . . . . . . . . . . 3
BOOM SUPPORT PAD . . . . . . . . . . 1
3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Intermediate Boom - Rear Section
1
2
3
2
7
4
5
8
6
4
7
6
6
8
4
8
907878/DP0208
178
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
Part
No.
L61708
L62731
L62732
L62715
PRINTED IN U.S.A.
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
1/16”X3X4” SHIM . . . . . . . . . . . . . . 4
1/8”X4X6” SHIM . . . . . . . . . . . . . . . 2
FLAT-BOLT LOCK . . . . . . . . . . . . . 10
Ref.
No.
Part
No.
05
06
07
08
L50836
L50251
L62733
L61709
179
Description
Qty.
Req.
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 8
3/8-16X3/4” BOLT . . . . . . . . . . . . . 12
1/16”X3X4” SHIM . . . . . . . . . . . . . . 4
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
907878/DP0208
DL Series Dynalift
Intermediate Boom - Front Section
3
1
4
2
5
7
6
8
9
4
10
2
9
11
4
907878/DP0208
180
8
7
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
Note a
L62715
L50836
L62733
L64132
L64143
L50367
L50147
PRINTED IN U.S.A.
Description
Qty.
Req.
INTERMEDIATE WELDMENT. . . . . 1
FLAT-BOLT LOCK . . . . . . . . . . . . . . 6
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 4
1/16”X3X4 SHIM . . . . . . . . . . . . . . . 6
3/8” PAD SPACER. . . . . . . . . . . . . . 2
1/2”X3X4 SHIM . . . . . . . . . . . . . . . . 2
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 8
3/8” LOCK WASHER . . . . . . . . . . . . 8
Ref.
No.
Part
No.
09
10
11
L61709
L61708
L50251
a
181
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 8
907878/DP0208
DL Series Dynalift
Intermediate Boom - Chain Group
1
2
3
4
5
6
3
2
7
11
1
3
11
15
16
10
14
10
3
5
6
13
9
3
8
907878/DP0208
9
19
18
4
10
12
17
11
8
20
182
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
Part
No.
01
02
03c
04
05
06
07
L10465
L400207
L71205
L64360
L49618
L49619
08
09
10
11
12
13
14
15
16
17
18
19
20
L69996
L71206
L50275
L520005
Note a
L560003
L64466
L64359
L50092
L50380
L64467
L50152
L64384
L64468
L64934
L71204
PRINTED IN U.S.A.
Description
Qty.
Req.
1/4-28 ZERK, STR. . . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 3
CHAIN SHEAVE WASHER . . . . . . . 6
CHAIN SHEAVE . . . . . . . . . . . . . . . 3
ROLLER BEARING . . . . . . . . . . . . . 3
INNER RING . . . . . . . . . . . . . . . . . . 3
REAR SHEAVE PIN . . . . . . . . . . . . 1
Note b and d (no groove in pin)
Note c (pin grooved for washer)
3/8-16X3 BOLT . . . . . . . . . . . . . . . . 3
LEAF CHAIN . . . . . . . . . . . . . . . . . . 3
3/32X1-1/4 COTTER PIN . . . . . . . 10
CHAIN ADJUST CLEVIS PIN . . . . . 3
ADJUSTABLE CLEVIS . . . . . . . . . . 3
1”-8 NUT . . . . . . . . . . . . . . . . . . . . . 6
1/2-20X1-1/4” BOLT . . . . . . . . . . . . 3
PIN, REAR CHAIN LOW INNER. . . 1
1/2” LOCK WASHER . . . . . . . . . . . . 3
CLEVIS, TOP REAR INNER . . . . . . 1
PIN, CHAIN REAR UPPER INNR . . 1
PIN, CHAIN SHEAVE . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
Qty.
Req.
a
257 Pitches - 192-3/4”
265 Pitches - 198-3/4”
277 Pitches - 207-3/4”
b
c
d
The following
L500286
L69041
L71204
L71205
L64490
907367
907894
update kits are available:
SHEAVE MNT. KIT, FRONT . . . . . . 1
MOUNT/FRONT SHEAVE . . . . . . . 3
PIN/FRONT SHEAVE . . . . . . . . . . . 1
WASHER/CHAIN SHEAVE . . . . . . 4
COLLAR/2” LOCK . . . . . . . . . . . . . 1
GUIDELINES/FOR WELDING . . . . 1
INSTRUCTIONS/SHEAVE MNT. . . 1
L500287
L69043
L71205
L71206
L64490
907367
907894
SHEAVE MNT. KIT, REAR . . . . . . . 1
MOUNT/REAR SHEAVE . . . . . . . . 2
PIN/REAR SHEAVE . . . . . . . . . . . . 1
COLLAR/2” LOCK . . . . . . . . . . . . . 1
183
907878/DP0208
DL Series Dynalift
Intermediate Boom - Hose Tray
9
8
7
6
10
5
4
3
2
1
907878/DP0208
184
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
Note a
L520004
L69524
L68349
L50143
L510008
Note b
L61699
L50147
PRINTED IN U.S.A.
Description
Qty.
Req.
INTERMEDIATE WELDMENT . . . . 1
TRAY BRACKET . . . . . . . . . . . . . . . 1
PLATE, CUSHION MNT (weld on)
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16-18X5/8” BOLT . . . . . . . . . . . . . 4
TRAY WELDMENT . . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 1
Ref.
No.
Part
No.
09
10
L50251
L50056
a
b
185
Description
Qty.
Req.
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
Inner Boom- Rear Section
7
1
8
2
3
4
5
9
6
3
10
4
3
11
2
3
1
1
907878/DP0208
186
PRINTED IN U.S.A.
DL Series Dynalift
Inner Boom - Rear Section
Ref.
No.
01
02
03
04
05
06
Part
No.
L61709
L62733
L62715
L50367
L64467
L560003
PRINTED IN U.S.A.
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
1/16”X3X4 SHIM . . . . . . . . . . . . . . . 4
FLAT-BOLT LOCK . . . . . . . . . . . . . 10
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 8
PIN, CHAIN REAR LOW INNER. . . 1
3/32X1-1/4” COTTER PIN . . . . . . . . 2
Ref.
No.
Part
No.
07
08
09
10
11
L66780
L66782
L66783
L50261
L50251
187
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
1/16”X3X8” SHIM . . . . . . . . . . . . . . 4
1/8”X3X8” SHIM . . . . . . . . . . . . . . . 2
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 8
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 4
907878/DP0208
DL Series Dynalift
Inner Boom Hose Tray
9
3
2
4
1
7
8
6
5
907878/DP0208
188
PRINTED IN U.S.A.
DL Series Dynalift
Inner Boom Hose Tray
Ref.
No.
01
02
03
04
05
06
07
Part
No.
Note a
L50147
L50251
L61699
L520004
L50143
L510008
PRINTED IN U.S.A.
Description
Qty.
Req.
INNER TRAY WELDMENT . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 1
3/8”-16X3/4” BOLT . . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
5/16”-18 NYLON INSERT NUT . . . . 2
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16-18X5/8” BOLT . . . . . . . . . . . . . 4
Ref.
No.
Part
No.
08
L69525
L68349
L79167
09
a
189
Description
Qty.
Req.
INNER TRAY BRACKET . . . . . . . . . 1
CUSHION MNT PLATE (weld on) AR
HOSE CLAMP ASSEMBLY . . . . . . . 1
40’ Low Boom, use P/.N L69863
42’ Low Boom, use P/.N L69522
907878/DP0208
Four-Section Low Boom
DL Series Dynalift
1
6
3
2
4
5
6
10
5
7
9
8
11
12
907878/DP0208
190
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
Part
No.
L50463
L520019
L69474
L10465
L530004
L50230
PRINTED IN U.S.A.
Description
Qty.
Req.
1/2-13X6” BOLT. . . . . . . . . . . . . . . . 1
BOOM PIVOT PIN. . . . . . . . . . . . . . 1
ZERK 1/4-28 STRAIGHT. . . . . . . . . 2
5/16” CLIP RETAINING NUT. . . . . 11
5/16-18X3/4” BOLT . . . . . . . . . . . . 11
Ref.
No.
Part
No.
07
08
09
10
11
12
L69866
L50056
L510008
L70952
L70864
L69492
191
Description
Qty.
Req.
REAR BOOM COVER. . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 5
5/16-18X5/8” BOLT . . . . . . . . . . . . . 5
BOOM SIDE COVER . . . . . . . . . . . 1
OUTER SECTION WELDMENT . . . 1
907878/DP0208
DL Series Dynalift
11
21
19
18
17
4
3
16
2
10
9
15
8
20
14
7
1
12
13
5
6
2
3
4
22
23
907878/DP0208
192
Low Boom
models only
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
Part
No.
L70864
L61709
L50251
L62733
L62734
L71020
L62715
L510007
L61709
L62734
L64143
L62715
L50261
L70972
L65640
L52048
L50141
L65638
L50491
PRINTED IN U.S.A.
Description
Qty.
Req.
OUTER SECTION WELD.. . . . . . . . 1
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
BOTTOM. SLIDE PAD 4X6 . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X7/8 . . . . . . . . 8
TOP SLIDE PAD 3X4 . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
SHIM .50 3X4 . . . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
RETAINER . . . . . . . . . . . . . . . . . . . 2
MOUNT PLATE . . . . . . . . . . . . . . . . 1
BUTT. HD. BOLT 5/16-18X1 . . . . . 2
PLAIN WASHER 5/16 . . . . . . . . . . 2
ANGLE INCLINOMETER . . . . . . . . 1
RD. HD. SCREW #8-32X5/8 . . . . . 2
Ref.
No.
Part
No.
14
19
20
21
22
23
L71004
L71021
L50380
L50152
L71005
L71001
L71000
L71007
L560003
L71006
L70242
L50092
L70429
L50403
00
00
00
-- ITEMS NOT SHOWN -(Boom Work Lights)
L70635
L70639
L70040
WORK LIGHT . . . . . . . . . . . . . . . . . 2
15
16
17
18
193
Description
Qty.
Req.
FIXED CLEVIS . . . . . . . . . . . . . . . . 1
SET SCREW #10-24X3/4 . . . . . . . 2
CAPSCREW 1/2-20X1-1/4 GR8 . . 3
LOCKWASHER 1/2” . . . . . . . . . . . . 2
CLEVIS PIN. . . . . . . . . . . . . . . . . . . 1
RETRACT LEAF CHAIN . . . . . . . . . 1
EXTEND LEAF CHAIN . . . . . . . . . . 2
CLEVIS PIN. . . . . . . . . . . . . . . . . . . 2
COTTER PIN 3/32X1-1/4 . . . . . . . . 4
THREADED INSERT. . . . . . . . . . . . 2
HEX NUT 1-8 . . . . . . . . . . . . . . . . . 4
BUMPER SUPPORT PAD. . . . . . . . 1
3/8”-16X1-3/4” BOLT . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
First Intermediate - Rear Section
8
4
16
5
10
6
9
7
19
13
11
19
9
15
14
12
17
18
1
7
6
5
4
3
2
907878/DP0208
194
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L70895
L61709
L62715
L510007
L61709
L62734
L62733
L62715
L50251
L71020
L71214
L62732
L62715
L50261
PRINTED IN U.S.A.
Description
Qty.
Req.
FIRST INTERM. SECT. WELD.. . . . 1
BOTT. SLIDE PAD 3X4 . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X7/8 . . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
TOP SLIDE PAD 4X6 . . . . . . . . . . . 2
HARDENED WASHER . . . . . . . . . . 2
SHIM .105X4X6. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
Ref.
No.
Part
No.
12
13
14
15
16
L71008
L49618
L49619
L10057
L71206
L50275
L520005
L61699
L50251
L50147
L70963
L71245
17
18
19
195
Description
Qty.
Req.
SHEAVE . . . . . . . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
GREASE ZERK 90 1/4-28. . . . . . . . 1
REAR SHEAVE PIN . . . . . . . . . . . . 1
CAPSCREW 3/8-16X3 . . . . . . . . . 1
NYLON INSERT NUT 3/8. . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
CAPSCREW 3/8-16X3/4 . . . . . . . . 1
LOCKWASHER 3/8 . . . . . . . . . . . . 1
HOSE TRAY WELDMENT. . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
First Intermediate - Front Section
23
17
19
20
24
21
27
25
26
18
22
16
27
14
21
1
20
15
19
17
18
23
7
4
3
6
2
5
12
11
8
13
2
3
4
10
10
9
907878/DP0208
196
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L70895
L61709
L62734
L62733
L50251
L61708
L63475
L62715
L50261
08
09
L71307
L71420
L62715
L50261
10
11
12
13
14
L71306
L71419
L71001
L500728
101028
L71021
L50380
L50142
L71005
L71007
L560003
PRINTED IN U.S.A.
Description
Qty.
Req.
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
TOP SLIDE PAD 4X6 . . . . . . . . . . . 1
SHIM .50X4X6. . . . . . . . . . . . . . . . . 1
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
SLIDE PAD W/CLAMP . . . . . . . . . . 2
Note a
Note b
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
SPACER PAD W/CLAMP . . . . . . . . 2
Note a
Note b
FIXED CLEVIS . . . . . . . . . . . . . . . . 1
Note c
Note d
SET SCREW #10-24X3/4 . . . . . . . 2
CAPSCREW 1/2-20X1-1/4GR8 . . 3
LOCKWASHER 1/2 . . . . . . . . . . . . 3
FIXED CHAIN PIN. . . . . . . . . . . . . . 1
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 1
Ref.
No.
Part
No.
15
16
17
18
19
20
21
22
23
24
25
26
27
101212
101212
L71006
L10465
L71017
L71008
L49618
L49619
L71214
L71212
L50275
L520005
L70963
L510008
L520004
L69524
L510008
L50143
L68349
L50092
L71245
Description
Qty.
Req.
Note c and e
Note d
GREASE ZERK, STR. 1/4-28 . . . . . 2
SHEAVE SPACER. . . . . . . . . . . . . . 2
CHAIN SHEAVE . . . . . . . . . . . . . . . 2
ROLLER BEARING . . . . . . . . . . . . . 2
INNER RING . . . . . . . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 2
SHEAVE PIN . . . . . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X3 . . . . . . . . . 2
NYLON INSERT NUT 3/8. . . . . . . . 2
CAPSCREW 5/16-18X5/8 . . . . . . . 2
NYLON INSERT NUT 5/16. . . . . . . 2
CAPSCREW 5/16-18X5/8 . . . . . . . 2
LOCKWASHER 5/16 . . . . . . . . . . . 2
CUSHION MNT PLATE (weld on)AR
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
a
Use with units equipped with single hydraulic
(individual) hoses.
b
Use with units equipped with “Twin Line” (dual)
hoses.
c
d
e
Must order 101028 Fixed Clevis, Ref. No. 12 on this
page.
197
907878/DP0208
DL Series Dynalift
Second Intermediate - Rear Section
15
4
5
16
6
17
7
12
14
13
11
20
22
19
10
9
21
18
22
8
20
7
6
5
3
3
2
4
2
1
See Hydraulic Components Pages For Hose Sheaves and Hardware
907878/DP0208
198
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
Part
No.
L70912
L71003
L62715
L50261
L61709
L62733
L62734
L62715
L50251
L71008
L49618
L49619
L71213
L71001
PRINTED IN U.S.A.
Description
Qty.
Req.
2ND INTERM. SECT. WELD. . . . . . 1
BOTT. SLIDE PAD 1.5X4 . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
SHIM .105X3X4” . . . . . . . . . . . . . . . 4
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
CHAIN SHEAVE . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
SHEAVE PIN . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
13
L71007
L560003
L71006
L71011
L66783
L62715
L50261
L71000
L71007
L560003
L71214
L50092
L71245
14
15
16
17
18
19
20
21
22
199
Description
Qty.
Req.
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
TOP SLIDE PAD 3X8 . . . . . . . . . . . 2
SHIM .105X3X8. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
CHAIN PIN . . . . . . . . . . . . . . . . . . . 2
COTTER PIN 3/32X1-1/4 . . . . . . . . 4
HARDENED WASHER . . . . . . . . . . 2
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Second Intermediate - Front Section
11
17
13
14
12
15
16
17
16
1
10
9
8
4
7
3
2
5
2
3
6
4
907878/DP0208
200
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L70912
L61709
L50367
L62733
L62734
L71020
L62715
L510007
L61709
L62734
L64143
PRINTED IN U.S.A.
Description
Qty.
Req.
SIDE SLIDE PAD 3X4” . . . . . . . . . . 2
CAPSCREW 3/8-16X1 . . . . . . . . . . 4
SHIM .06X3X4” . . . . . . . . . . . . . . . . 2
SHIM .105X3X4” . . . . . . . . . . . . . . . 2
BOTT. SLIDE PAD 4X6” . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X7/8” . . . . . . . . 8
TOP SLIDE PAD 3X4” . . . . . . . . . . . 2
SHIM .105X3X4” . . . . . . . . . . . . . . . 2
SHIM .50X3X4” . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
10
L62715
L50261
L71206
L10057
L49619
L49618
L71008
L71214
L71245
11
12
13
14
15
16
17
201
Description
Qty.
Req.
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2” . . . . . . 4
SHEAVE PIN . . . . . . . . . . . . . . . . . . 1
GREASE ZERK 90 1/4-28. . . . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
CHAIN SHEAVE . . . . . . . . . . . . . . . 1
HARDENED WASHER . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
8
4
5
9
6
7
10
16
13
14
12
11
15
7
6
1
5
4
3
3
2
2
907878/DP0208
202
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
L70943
100120
L71003
L62715
L510007
L61709
L62733
L62734
L62715
L50367
L71011
L66783
PRINTED IN U.S.A.
Description
Qty.
Req.
INNER WELDMENT . . . . . . . . . . . . 1
Note a
Note b
BOTT. SLIDE PAD 1.5X4.0 . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X7/8 . . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 2
SHIM .06X3X4. . . . . . . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1 . . . . . . . . . . 4
TOP SLIDE PAD 3X8 . . . . . . . . . . . 2
SHIM .105X3X8. . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
10
L62715
L50261
L71006
L71007
L560003
L71001
L71007
L560003
11
12
13
14
15
Description
Qty.
Req.
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
Note c
Note d
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 2
16
101212
101212
L50092
a
b
c
Must also order 101028 Fixed Clevis, Ref. No. 12
on page 167.
d
203
907878/DP0208
Low Boom
DL Series Dynalift
Inner Boom - Front Section
15
Front Inner Boom
Bell Crank Pivot
12
1
2
12
13
Attachment Pivot
3
4
5
7
6
10
8
14
11
16
10
9
7
907878/DP0208
204
PRINTED IN U.S.A.
DL Series Dynalift
Low Boom
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
Part
No.
L50462
L69975
L71547
L520019
L68046
L71546
L69965
L69952
L50230
L69724
L69968
L69973
L69964
L10465
L70310
L71550
L69963
15
16b
Note d
Note e
L69723
PRINTED IN U.S.A.
Description
Qty.
Req.
1/2-13X5” BOLT. . . . . . . . . . . . . . . . 1
BELL CRANK PIVOT PIN . . . . . . . . 1
Note f
Note g
SPRING BUSHING . . . . . . . . . . . . . 1
Note a and b
Note c
SPRING BUSHING . . . . . . . . . . . . . 1
BELL CRANK END PIN. . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 6
PIVOT PIN CAP . . . . . . . . . . . . . . AR
Z-BAR LINK PIN . . . . . . . . . . . . . . . 1
Z-BAR SPACER . . . . . . . . . . . . . . . 2
ZERK 1/4-28 STRAIGHT. . . . . . . . . 3
BELL CRANK W/BUSHING . . . . . . 1
(Includes item 4)
Note f
Note g
Z-BAR LINK. . . . . . . . . . . . . . . . . . . 1
(Includes items 5, 11)
LOW INNER BOOM WELDMENT . 1
Note a and b
Note c
BUSHING . . . . . . . . . . . . . . . . . . . . 2
Ref.
No.
a
Part
No.
Description
----SERIAL NUMBERS---DL6L SN 25415 and before
b
DL10L SN 45111 Thru SN 45170
c
d
----INNER BOOM PART NUMBERS---Order PN 100118 pin and select the appropriate
inner boom from note e, below.
e
40’ Low
42’ Low
44’ Low
55’ Low
f
g
205
Qty.
Req.
Boom,
Boom,
Boom,
Boom,
use
use
use
use
PN
PN
PN
PN
100111
100109
100110
100120
907878/DP0208
Low Boom
DL Series Dynalift
Manual Dynacarrier® Bracket
(Low Boom Models)
Later Style Pivot Pin
2
Bell Crank Pivot
4
1
5
6
10
8
3
8
14
15
7
6
12
8
12
Attachment Pivot
13
9
11
12
9
10
16
16
17
Early Style Pivot Pin
907878/DP0208
206
18
PRINTED IN U.S.A.
DL Series Dynalift
Low Boom
(Low Boom Models)
Ref.
No.
Part
No.
01
02bc
03
04bc
05bc
06
07
08
09
10
11
12
13
L70366
100247
101351
L69780
L69728
100118
L50986
L520019
L10465
L67448
L520005
L67106
L67105
L67100
L67099
L50261
L10465
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
DYNACARRIER WELDMENT. . . . . 1
Note a
Note b and c (Includes item 2)
BUSHING . . . . . . . . . . . . . . . . . . . . 1
CARRIER PIVOT PIN . . . . . . . . . . . 1
Note a (21”X2” w/notch) . . . . . . . . . 1
Note b (14”x2” w/notch). . . . . . . . . . 1
Note c (14”x2” w/hole) . . . . . . . . . . . 1
1/2-13X4-1/2” BOLT . . . . . . . . . . . . 1
1/4-28 GREASE ZERK, STR. . . . . . 3
LATCH SPRING . . . . . . . . . . . . . . . 1
LOCK COUPLER BAR . . . . . . . . . . 2
LOCK PIN WELDMENT . . . . . . . . . 2
LOCK HANDLE WELDMENT . . . . . 1
BRONZE BUSHING . . . . . . . . . . . . 1
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 4
1/4-28 GREASE ZERK, STR. . . . . . 4
14
15
16ab
17ab
18ab
L67107
L276632
L50230
L69724
L69725
a
Description
LATCH COUPLER BAR . . . . . . . . . 1
1” RETAINING CLIP . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 4
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
PIN LOCK CAP . . . . . . . . . . . . . . . . 1
b
DL6L SN 25416 thru SN 25570
DL10L SN 45111 Thru SN 45170
c
207
Qty.
Req.
907878/DP0208
Low Boom
DL Series Dynalift
Dynattach® Bracket
(All Low Boom Models)
Bell Crank Pivot
2
1
3
4
5
6
2
Attachment Pivot
(Boom)
7
15
15
10
14
13
8
9
12
6
11
6
4
Early Style
907878/DP0208
208
16
PRINTED IN U.S.A.
DL Series Dynalift
Low Boom
Dynattach® Bracket
(All Low Boom Models)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
Part
No.
101053
L10465
L69968
L69724
L50143
L50230
L50462
L520019
L69728
100118
101351
L66453
L50646
PRINTED IN U.S.A.
Description
Qty.
Req.
DYNATTACH® WELDMENT . . . . . 1
1/4” -28 STR GREASE ZERK . . . . . 2
Z-BAR LINK PIN . . . . . . . . . . . . . . . 1
PIN CAP . . . . . . . . . . . . . . . . . . . . . 1
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16”X3/4” BOLT . . . . . . . . . . . . . . . 2
1/2”X5” BOLT. . . . . . . . . . . . . . . . . . 1
1/2” NYLON INSERT NUT . . . . . . . 1
Note a (with notched end)
Note b (with hole for bolt)
BUSHING . . . . . . . . . . . . . . . . . . . . 1
LOCK AND PIN ASSEMBLY . . . . . . 1
3/16”X1-3/4” ROLL PIN . . . . . . . . . . 1
Ref.
No.
13
14
15
16
a
b
209
Part
No.
L65097
L65098
L66456
L69725
Description
Qty.
Req.
LOCK SPRING . . . . . . . . . . . . . . . . 1
SPRING MOUNT. . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 2
PIN LOCK CAP . . . . . . . . . . . . . . . . 1
907878/DP0208
Three-Section High Boom
DL Series Dynalift
9
5
3
8
6
4
7
5
2
1
6
10
6
11
5
12
15
14
13
16
907878/DP0208
210
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
Note a
L400207
L50608
L69994
L50956
L50519
L69480
L530004
L50230
L69534
PRINTED IN U.S.A.
Description
Qty.
Req.
THRUST WASHER . . . . . . . . . . . . . 2
3/16X4” COTTER PIN . . . . . . . . . . . 2
EXTEND CYLINDER PIN . . . . . . . . 1
3/4-10X2-1/2” BOLT . . . . . . . . . . . . 8
EXT. CYL. MOUNT WLDMNT . . . . . 1
5/16” CLIP RETAINING NUT. . . . . . 6
5/16-18X3/4” BOLT . . . . . . . . . . . . . 6
REAR BOOM COVER. . . . . . . . . . . 1
Ref.
No.
Part
No.
11
12
13
14
15
16
L70420
L50463
L69474
L520019
L10465
L69492
a
40’ High Boom, use PN L70421
211
Description
Qty.
Req.
TRUNION SHIM . . . . . . . . . . . . . . . 1
1/2-13X6” BOLT. . . . . . . . . . . . . . . . 1
BOOM PIVOT PIN. . . . . . . . . . . . . . 1
1/4-28 ZERK, STRAIGHT . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Outer Boom Side Cover
6
5
4
2
5
3
2
1
907878/DP0208
212
PRINTED IN U.S.A.
DL Series Dynalift
Outer Boom Side Cover
Ref.
No.
01
02
03
04
05
06
Part
No.
Note a
L50056
L79167
L530004
L50230
Note b
PRINTED IN U.S.A.
Description
Qty.
Req.
5/16” FLARE NUT . . . . . . . . . . . . . . 6
5/16” CLIP RETAINING NUT. . . . . . 5
5/16-18X3/4” BOLT . . . . . . . . . . . . 10
OUTER SIDE COVER. . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
a
b
213
Qty.
Req.
907878/DP0208
DL Series Dynalift
26
13
27
25
31
32
28
24
16
18
16
17 18
1
30
29
23
22
2
21
3
4
16
5
16
20
18
19
17
15
9
13
19
17
10
14
12
907878/DP0208
214
8
7
6
11
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
Part
No.
Note a
L70242
L65640
L50141
L52048
L50491
L50136
L65638
L520004
L50061
L52026
L70639
L70040
L70462
L520005
L50835
L62733
L50251
L50147
L62715
L61708
PRINTED IN U.S.A.
Description
Qty.
Req.
5/16-18 NUT INSERT . . . . . . . . . . . 2
BOOM ANGLE IND. PLATE . . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . . 2
5/16-18X1” BUTTON HD BOLT. . . . 2
#8X5/8” RND HD MACH SCREW. . 2
#10 LOCK WASHER . . . . . . . . . . . . 2
INCLINOMETER - ANGLE IND. . . . 1
3/8-16 FLARE NUT . . . . . . . . . . . . . 2
3/8-16X1-1/4” BOLT . . . . . . . . . . . . 4
WORK LIGHT . . . . . . . . . . . . . . . . . 2
LIGHT HARNESS (not shown). . . . 1
5/16-18X2” BOLT. . . . . . . . . . . . . . . 2
.06X3X4 SHIM. . . . . . . . . . . . . . . . . 6
3/8-16X3/4” BOLT . . . . . . . . . . . . . 16
3/8” LOCK WASHER . . . . . . . . . . . 12
FLAT-BOLT LOCK . . . . . . . . . . . . . . 4
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
21
22
23
24
25
26
L61709
L64143
L64132
L50836
L70635
L64359
27
28
29
30
31
32
L50380
L560003
L64384
L64468
L50152
Note b
a
b
215
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
.50X3X4 SHIM. . . . . . . . . . . . . . . . . 2
3/8” PAD SPACER. . . . . . . . . . . . . . 2
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 4
ADJUSTABLE CLEVIS PIN. . . . . . . 3
(does not include nuts or cotter pins)
1/2-20X1-1/4” GRD 8 BOLT . . . . . . 3
3/32X1-1/4” COTTER PIN . . . . . . . . 2
CLEVIS . . . . . . . . . . . . . . . . . . . . . . 1
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
1/2” LOCK WASHER . . . . . . . . . . . . 3
LEAF CHAIN . . . . . . . . . . . . . . . . . . 3
907878/DP0208
DL Series Dynalift
1
2
3
2
7
4
5
8
6
4
7
6
6
8
4
8
907878/DP0208
216
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
Part
No.
L61708
L62731
L62732
L62715
PRINTED IN U.S.A.
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
.06X3X4” SHIM . . . . . . . . . . . . . . . . 4
.105X4X6” SHIM . . . . . . . . . . . . . . . 2
FLAT-BOLT LOCK . . . . . . . . . . . . . 10
Ref.
No.
Part
No.
05
06
07
08
L50836
L50251
L62733
L61709
217
Description
Qty.
Req.
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 8
3/8-16X3/4” BOLT . . . . . . . . . . . . . 12
.06X3X4” SHIM . . . . . . . . . . . . . . . . 4
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
907878/DP0208
DL Series Dynalift
3
1
4
2
5
7
6
8
9
4
10
2
9
11
4
907878/DP0208
218
8
7
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
Note a
L62715
L50836
L62733
L64132
L64143
L50367
L50147
PRINTED IN U.S.A.
Description
Qty.
Req.
INTERMEDIATE WELDMENT. . . . . 1
FLAT-BOLT LOCK . . . . . . . . . . . . . . 6
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 4
.06X3X4 SHIM. . . . . . . . . . . . . . . . . 6
3/8” PAD SPACER. . . . . . . . . . . . . . 2
.50X3X4 SHIM. . . . . . . . . . . . . . . . . 2
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 8
3/8” LOCK WASHER . . . . . . . . . . . . 8
Ref.
No.
Part
No.
09
10
11
L61709
L61708
L50251
a
219
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 8
907878/DP0208
DL Series Dynalift
1
2
3
4
5
6
3
2
7
11
1
3
11
15
16
10
14
10
3
5
6
13
9
3
8
907878/DP0208
9
19
18
4
10
12
17
11
8
20
220
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
Part
No.
01
02
03c
04
05
06
07
L10465
L400207
L71205
L64360
L49618
L49619
08
09
10
11
12
13
14
15
16
17
18
19
20
L69996
L71206
L50275
L520005
Note a
L560003
L64466
L64359
L50092
L50380
L64467
L50152
L64384
L64468
L64934
L71204
PRINTED IN U.S.A.
Description
Qty.
Req.
1/4-28 ZERK, STR. . . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 3
CHAIN SHEAVE WASHER . . . . . . . 6
CHAIN SHEAVE . . . . . . . . . . . . . . . 3
ROLLER BEARING . . . . . . . . . . . . . 3
INNER RING . . . . . . . . . . . . . . . . . . 3
REAR SHEAVE PIN . . . . . . . . . . . . 1
3/8-16X3 BOLT . . . . . . . . . . . . . . . . 3
LEAF CHAIN . . . . . . . . . . . . . . . . . . 3
3/32X1-1/4 COTTER PIN . . . . . . . 10
CHAIN ADJUST CLEVIS PIN . . . . . 3
1”-8 NUT . . . . . . . . . . . . . . . . . . . . . 6
1/2-20X1-1/4” BOLT . . . . . . . . . . . . 3
PIN, REAR CHAIN LOW INNER. . . 1
1/2” LOCK WASHER . . . . . . . . . . . . 3
CLEVIS, TOP REAR INNER . . . . . . 1
PIN, CHAIN REAR UPPER INNR . . 1
PIN, CHAIN SHEAVE . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
Qty.
Req.
a
257 Pitches - 192-3/4”
265 Pitches - 198-3/4”
277 Pitches - 207-3/4”
b
c
d
The following
L500286
L69041
L71204
L71205
L64490
907367
907894
update kits are available:
SHEAVE MNT. KIT, FRONT . . . . . . 1
MOUNT/FRONT SHEAVE . . . . . . . 3
PIN/FRONT SHEAVE . . . . . . . . . . . 1
COLLAR/2” LOCK . . . . . . . . . . . . . 1
L500287
L69043
L71205
L71206
L64490
907367
907894
SHEAVE MNT. KIT, REAR . . . . . . . 1
MOUNT/REAR SHEAVE . . . . . . . . 2
PIN/REAR SHEAVE . . . . . . . . . . . . 1
COLLAR/2” LOCK . . . . . . . . . . . . . 1
221
907878/DP0208
DL Series Dynalift
9
8
7
6
5
4
3
2
1
907878/DP0208
222
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
Note a
L520004
L69524
L68349
L50143
L510008
Note b
L61699
L50147
L50251
L50056
PRINTED IN U.S.A.
Description
Qty.
Req.
INTERMEDIATE WELDMENT . . . . 1
TRAY BRACKET . . . . . . . . . . . . . . . 1
PLATE, CUSHION MNT (weld on)
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16-18X5/8” BOLT . . . . . . . . . . . . . 4
TRAY WELDMENT . . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
a
b
223
Qty.
Req.
907878/DP0208
DL Series Dynalift
Inner Boom- Rear Section
7
1
8
2
3
4
5
9
6
3
10
4
3
11
2
3
1
1
907878/DP0208
224
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
Part
No.
L61709
L62733
L62715
L50367
L64467
L560003
PRINTED IN U.S.A.
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 6
0.06X3X4 SHIM. . . . . . . . . . . . . . . . 4
FLAT-BOLT LOCK . . . . . . . . . . . . . 10
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 8
PIN, CHAIN REAR LOW INNER. . . 1
3/32X1-1/4” COTTER PIN . . . . . . . . 2
Ref.
No.
Part
No.
07
08
09
10
11
L66780
L66782
L66783
L50261
L50251
225
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 2
0.06X3X8” SHIM . . . . . . . . . . . . . . . 4
0.105X3X8” SHIM . . . . . . . . . . . . . . 2
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 8
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 4
907878/DP0208
Four-Section High Boom
DL Series Dynalift
6
1
5
7
4
2
3
907878/DP0208
226
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
Part
No.
L70863
L69534
L50230
L530004
L69492
L70956
L510008
L530004
L510008
L50056
PRINTED IN U.S.A.
Description
Qty.
Req.
OUTER SECTION WELDMENT.. . . 1
REAR COVER. . . . . . . . . . . . . . . . . 1
5/16”-18X3/4 BOLT . . . . . . . . . . . . 6
5/16” RET. NUT FASTNR. . . . . . . . 6
SIDE COVER . . . . . . . . . . . . . . . . . 1
5/16”-18X5/8 BOLT. . . . . . . . . . . . . 5
5/16” RET. NUT FASTNR. . . . . . . . 5
5/16”-18X5/8” BOLT . . . . . . . . . . . 5
5/16” FLANGE NUT . . . . . . . . . . . . 5
Ref.
No.
Part
No.
05
06
07
L520019
L50463
L69474
227
Description
Qty.
Req.
1/2”-13 NYLON INSERT NUT . . . . . 2
1/2”-13X6” BOLT . . . . . . . . . . . . . . 2
PIVOT PIN . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
21
19
18
17
16
4
3
15
2
14
20
10
9
1
8
7
12
2
11
13
5
6
3
4
907878/DP0208
228
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L70863
L61709
L50251
L62733
L62734
L71020
L62715
L510007
L61709
L62734
L64143
L62715
L50261
P272700
L50282
L50152
PRINTED IN U.S.A.
Description
Qty.
Req.
OUTER SECTION WELDMENT.. . . 1
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
BOTT. SLIDE PAD 4X6 . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X7/8 . . . . . . . . 8
TOP SLIDE PAD 3X4 . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
SHIM .50 3X4 . . . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
ISOLATOR . . . . . . . . . . . . . . . . . . . . 1
CAPSCREW 1/2-13X1 . . . . . . . . . 1
LOCKWASHER 1/2 . . . . . . . . . . . . 1
Ref.
No.
Part
No.
12
19
20
21
L65640
L52048
L50141
L65638
L50491
L71004
L71021
L50380
L50152
L71005
L71001
L71000
L71007
L560003
L71006
L70242
L50092
00
00
00
-- ITEMS NOT SHOWN -(Boom Work Lights)
L70635
L70639
L70040
WORK LIGHT . . . . . . . . . . . . . . . . . 2
13
14
15
16
17
18
229
Description
Qty.
Req.
MOUNT PLATE . . . . . . . . . . . . . . . . 1
BUTT. HD. BOLT 5/16-18X1 . . . . . 2
PLAIN WASHER 5/16 . . . . . . . . . . 2
ANGLE INCLINOMETER . . . . . . . . 1
RD. HD. SCREW #8-32X5/8 . . . . . 2
FIXED CLEVIS . . . . . . . . . . . . . . . . 1
SETSCREW #10-24X3/4 . . . . . . . 2
CAPSCREW 1/2-20X1-1/4 GR8 . . 3
LOCKWASHER 1/2 . . . . . . . . . . . . 3
CLEVIS PIN. . . . . . . . . . . . . . . . . . . 1
CLEVIS PIN. . . . . . . . . . . . . . . . . . . 2
COTTER PIN 3/32X1-1/4 . . . . . . . . 4
THREADED INSERT. . . . . . . . . . . . 2
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 4
907878/DP0208
DL Series Dynalift
8
16
9
15
11
10
19
14
4
13
19
5
6
1
12
17
7
11
18
7
6
5
4
3
2
907878/DP0208
230
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
L70894
L61709
L62715
L510007
L61709
L62734
L62733
L62715
L50251
L71020
L62732
L62715
L50261
PRINTED IN U.S.A.
Description
Qty.
Req.
BOTTOM. SLIDE PAD 3X4 . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X7/8 . . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
TOP SLIDE PAD 4X6 . . . . . . . . . . . 2
SHIM .105X4X6. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
Ref.
No.
Part
No.
11
12
13
14
15
16
L71214
L71008
L49618
L49619
L10057
L71206
L50275
L520005
L61699
L50251
L50147
L70962
L71245
17
18
19
231
Description
Qty.
Req.
THRUSTWASHER . . . . . . . . . . . . . 1
SHEAVE . . . . . . . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
GREASE ZERK 90 1/4-28. . . . . . . . 1
REAR SHEAVE PIN . . . . . . . . . . . . 1
CAPSCREW 3/8-16X3 . . . . . . . . . 1
NYLON INSERT NUT 3/8. . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
CAPSCREW 3/8-16X3/4 . . . . . . . . 1
LOCKWASHER 3/8 . . . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
16
19
18
20
21
24
17
26
23
27
22
27
13
21
14
20
15
18
19
4
17
3
16
2
7
6
1
2
5
3
11
8
4
10
12
25
9
907878/DP0208
25
232
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L70894
L61709
L62734
L62733
L50251
L61708
L63475
L62715
L50261
08
09
10
11
12
13
14
L71307
L71420
L62715
L50261
L71005
L71001
L500728
101028
L71021
L50380
L50152
L71006
L71007
L560003
15
16
101212
101212
L71212
L50275
L520005
PRINTED IN U.S.A.
Description
Qty.
Req.
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 4
3/8”-16X3/4” BOLT . . . . . . . . . . . . . 8
TOP SLIDE PAD 4X6 . . . . . . . . . . . 1
SHIM .50X4X6. . . . . . . . . . . . . . . . . 1
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
3/8”-16X1”-1/2 BOLT . . . . . . . . . . . 4
SLIDE PAD W/CLAMP . . . . . . . . . . 2
Note a
Note b
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
3/8”-16X1-1/2” BOLT . . . . . . . . . . . 8
FIXED CHAIN PIN. . . . . . . . . . . . . . 1
FIXED CLEVIS . . . . . . . . . . . . . . . . 1
Note c
Note d
SETSCREW #10-24X3/4” . . . . . . . 2
1/2”-20X1-1/4” BOLT GR8 . . . . . . . 3
LOCKWASHER 1/2 . . . . . . . . . . . . 3
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 1
Note c and e
Note d
SHEAVE PIN . . . . . . . . . . . . . . . . . . 2
3/8”-16X3” BOLT . . . . . . . . . . . . . . 2
3/8” NYLON INSERT NUT . . . . . . . 2
Ref.
No.
Part
No.
17
18
19
20
21
22
23
L10465
L71017
L71008
L49618
L49619
L71214
L69524
L510008
L50143
L68349
L70962
L510008
L520004
24
25
26
27
L71306
L71419
L50092
L71245
Description
Qty.
Req.
GREASE ZERK, STR. 1/4-28 . . . . . 2
SHEAVE SPACER. . . . . . . . . . . . . . 2
CHAIN SHEAVE . . . . . . . . . . . . . . . 2
ROLLER BEARING . . . . . . . . . . . . . 2
INNER RING . . . . . . . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 2
5/16”-18X5/8” BOLT . . . . . . . . . . . 2
LOCKWASHER 5/16 . . . . . . . . . . . 2
CUSHION, MNT PLATE (weld on)
5/16”-18X5/8” BOLT . . . . . . . . . . . 2
5/16” NYLON INSERT NUT . . . . . . 2
SPACER PAD W/CLAMP . . . . . . . . 2
Note a
Note b
HEX NUT 1”-8 . . . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
a
Use with units equipped with single hydraulic
(individual) hoses.
b
Use with units equipped with “Twin Line” (dual)
hoses.
c
d
e
Must order 101028 Fixed Clevis, Ref. No 12 on this
page.
233
907878/DP0208
DL Series Dynalift
21
4
5
16
6
17
13
7
12
15
14
20
19
22
10
9
18
8
11
22
20
7
6
3
5
1
3
2
4
2
See Hydraulic Components Pages For Hose Sheaves and Hardware
907878/DP0208
234
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
Part
No.
L70912
L71003
L62715
L50261
L61709
L62733
L62734
L62715
L50251
L71008
L49618
L49619
L71213
L71001
PRINTED IN U.S.A.
Description
Qty.
Req.
BOTTOM. SLIDE PAD 1.5X4 . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 4
SHIM .06X3X4” . . . . . . . . . . . . . . . . 4
SHIM .105X3X4. . . . . . . . . . . . . . . . 4
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X3/4 . . . . . . . . 8
CHAIN SHEAVE . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
SHEAVE PIN . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
13
L71007
L560003
L71006
L50092
L66783
L62715
L50261
L71000
L71007
L560003
L71214
L71011
L71245
14
15
16
17
18
19
20
21
22
235
Description
Qty.
Req.
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 2
SHIM .105X3X8. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
CHAIN PIN . . . . . . . . . . . . . . . . . . . 2
COTTER PIN 3/32X1-1/4 . . . . . . . . 4
THRUSTWASHER . . . . . . . . . . . . . 2
TOP SLIDE PAD 3X8 . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
11
17
13
14
15
12
17
16
16
10
9
4
8
3
2
7
1
5
2
6
3
4
907878/DP0208
236
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L70912
L61709
L50367
L62733
L62734
L71020
L62715
L510007
L61709
L62734
L64143
PRINTED IN U.S.A.
Description
Qty.
Req.
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 2
CAPSCREW 3/8-16X1 . . . . . . . . . . 4
SHIM .06X3X4. . . . . . . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
BOTT. SLIDE PAD 4X6 . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X7/8 . . . . . . . . 8
TOP SLIDE PAD 3X4 . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
SHIM .50X3X4. . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
10
L62715
L50261
L71206
L50275
L520005
L10465
L49619
L49618
L71008
L71214
L71245
11
12
13
14
15
16
17
237
Description
Qty.
Req.
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1-1/2 . . . . . . . 4
SHEAVE PIN . . . . . . . . . . . . . . . . . . 1
CAPSCREW 3/8-16X3 . . . . . . . . . . 1
NYLON INSERT NUT 3/8. . . . . . . . 1
GREASE ZERK STR. 1/4-28 . . . . . 1
INNER RING . . . . . . . . . . . . . . . . . . 1
ROLLER BEARING . . . . . . . . . . . . . 1
CHAIN SHEAVE . . . . . . . . . . . . . . . 1
THRUSTWASHER . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
8
9
4
6
10
7
16
5
13
14
11
15
12
7
6
5
4
3
1
2
907878/DP0208
238
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
L70942
100119
L71003
L62715
L510007
L61709
L62733
L62734
L62715
L50367
L71011
L66783
PRINTED IN U.S.A.
Description
Qty.
Req.
INNER WELDMENT . . . . . . . . . . . . 1
Note a
Note b
BOTT. SLIDE PAD 1.5X4.0 . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X7/8 . . . . . . . . 4
SIDE SLIDE PAD 3X4 . . . . . . . . . . . 2
SHIM .06X3X4. . . . . . . . . . . . . . . . . 2
SHIM .105X3X4. . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK . . . . . . . . . . . . . . 2
CAPSCREW 3/8-16X1 . . . . . . . . . . 4
TOP SLIDE PAD 3X8 . . . . . . . . . . . 2
SHIM .105X3X8. . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
10
L62715
L50261
L71006
L71007
L560003
L71001
L71007
L560003
11
12
13
14
15
Description
Qty.
Req.
BOLT FLAT LOCK . . . . . . . . . . . . . . 4
CAPSCREW 3/8-16X1-1/2 . . . . . . . 8
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
CHAIN PIN . . . . . . . . . . . . . . . . . . . 1
COTTER PIN 3/32X1-1/4 . . . . . . . . 2
Note c
Note d
HEX NUT 1-8. . . . . . . . . . . . . . . . . . 2
16
101212
101212
L50092
a
b
c
Must also order 101028 Fixed Clevis, Ref. No. 12
on page 205.
d
239
907878/DP0208
High Boom
DL Series Dynalift
(All High Boom Models)
8
9
7
10
11
6
5
4
3
2
1
12
Attachment Pivot
907878/DP0208
240
PRINTED IN U.S.A.
DL Series Dynalift
High Boom
Ref.
No.
Part
No.
01a
01bc
02
03
Note d
Note e
L520004
L69525
L68349
L50143
L510008
Note f
L50147
L50251
L79167
L50056
L61699
L69723
04
05
06
07
08
09
10
11
12b
Description
Qty.
Req.
INNER WELDMENT . . . . . . . . . . . . 1
INNER WELDMENT . . . . . . . . . . . . 1
CUSHION, MNT PLATE (weld on)
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16-18X5/8” BOLT . . . . . . . . . . . . . 4
INNER TRAY WELDMENT . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 1
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 2
Ref.
No.
a
Description
DL10H SN 40165 Thru SN 40414
c
----INNER BOOM PART NUMBERS---Order PN 100118 pin and select the appropriate
inner boom from note e, below.
e
40’ High
42’ High
44’ High
55’ High
f
241
Qty.
Req.
----SERIAL NUMBERS---DL6H SN 20372 and before
b
d
PRINTED IN U.S.A.
Part
No.
Boom,
Boom,
Boom,
Boom,
use
use
use
use
PN
PN
PN
PN
100112
100113
100114
100119
907878/DP0208
High Boom
DL Series Dynalift
Earlier Style Pivot Pin
17
3
17
16
18
Latest Style Pivot Pin
2
3
1
4
Attachment Pivot
5
6
10
8
8
14
15
7
6
12
8
12
Tilt Cylinder Pivot
13
9
11
12
907878/DP0208
9
10
242
PRINTED IN U.S.A.
DL Series Dynalift
High Boom
® Bracket
Manual Dynacarrier
Ref.
No.
Part
No.
01
02bc
03
04
05
06
07
08
09
10
11
12
13
14
L69781
100249
101351
L69780
L69728
100118
L50986
L520019
L10465
L67448
L520005
L67106
L67105
L67100
L67099
L50261
L10465
L67107
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
DYNACARRIER WELDMENT. . . . . 1
Note a
Note b and c (Includes item 2)
BUSHING . . . . . . . . . . . . . . . . . . . . 1
Note a (21”X2” w/notch) . . . . . . . . . 1
Note b (14”x2” w/notch). . . . . . . . . . 1
Note c (14”x2” w/hole) . . . . . . . . . . . 1
1/2-13X4-1/2” BOLT . . . . . . . . . . . . 1
1/4-28 GREASE ZERK, STR. . . . . . 3
LATCH SPRING . . . . . . . . . . . . . . . 1
LOCK COUPLER BAR . . . . . . . . . . 2
LOCK PIN WELDMENT . . . . . . . . . 2
LOCK HANDLE WELDMENT . . . . . 1
BRONZE BUSHING . . . . . . . . . . . . 1
3/8-16X1-1/2” BOLT . . . . . . . . . . . . 4
1/4-28 GREASE ZERK, STR. . . . . . 4
LATCH COUPLER BAR . . . . . . . . . 1
15
16ab
17ab
18ab
L276632
L69724
L50230
L69725
a
Description
1” RETAINING CLIP . . . . . . . . . . . . 1
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 6
PIN LOCK CAP . . . . . . . . . . . . . . . . 1
b
DL10H SN 40165 Thru SN 40414
DL12H SN 50121 Thru SN 50168
c
243
Qty.
Req.
907878/DP0208
High Boom
DL Series Dynalift
Dynattach® Bracket
Earlier Style Pivot Pin
7
7
9
Attachment Pivot
(Boom)
16
1
2
4
3
5
2
6
15
15
10
14
9
13
12
Tilt Cylinder Pivot
8
7
11
907878/DP0208
244
PRINTED IN U.S.A.
DL Series Dynalift
High Boom
Dynattach® Bracket
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
Part
No.
101055
L10465
101351
L69728
100118
L50462
L520019
L50230
L50143
L69724
L69727
L66453
L50646
L65097
L65098
PRINTED IN U.S.A.
Description
Qty.
Req.
DYNATTACH® WELDMENT. . . . . . 1
1/4” -28 STR GREASE ZERK . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 1
Note a (with notched end)
Note b (with hole for bolt)
1/2”X5” BOLT. . . . . . . . . . . . . . . . . . 1
1/2” NYLON INSERT NUT . . . . . . . 1
5/16”X3/4” BOLT . . . . . . . . . . . . . . . 2
5/16” LOCK WASHER . . . . . . . . . . . 2
PIN CAP . . . . . . . . . . . . . . . . . . . . . 1
PIN, TILT CYLINDER . . . . . . . . . . . 1
LOCK AND PIN ASSEMBLY . . . . . . 1
3/16”X1-3/4” ROLL PIN . . . . . . . . . . 1
LOCK SPRING . . . . . . . . . . . . . . . . 1
SPRING MOUNT. . . . . . . . . . . . . . . 1
Ref.
No.
15
16a
a
b
245
Part
No.
L66456
L69725
Description
Qty.
Req.
BUSHING . . . . . . . . . . . . . . . . . . . . 2
PIN LOCK CAP . . . . . . . . . . . . . . . . 1
907878/DP0208
Hydraulics
DL Series Dynalift
Hydraulic Pump and Accumulator
FRONT
2
7
5
6
1
3
T
4
9
PF
32
29
JP
33
30
8
34
11
31
10
12
27
28
35
17
E
26
A
B
25
C
D
13
14
23
24
22
12
16
15
36
37
39 38
STAC
VALVE
19
21
17
18
20
907878/DP0208
19
246
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Hydraulic Pump and Accumulator
Ref.
No.
Part
No.
Description
01
02
03
04a
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
L69917
105166
L64856
L443004
L69499
L69920
L62842
L99927
L70493
L444060
L70229
L444002
P471997
L51972
L69571
L446048
L444080
L70267
L445002
L70188
L70033
21
22
23
L70465
L69543
L71271
24
25
26
27
28
29
30
L60986
L50152
P47159
L64660
L69932
L69931
31
32
33
34
35
Qty.
Req.
HOSE, -16 . . . . . . . . . . . . . . . . . . . . 1
Note x (A16/D16 62”)
Note y (A16/A16 62”)
ADAP, -16JICFS -16JICM 90 DEG . 2
ADAP, -12ORM -16JICM R-TEE . . . 1
TUBE, PUMP OUT . . . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
ADAP, -4ORM -6JICM 90 DEG . . . . 1
RELIEF VALVE 350PSI . . . . . . . . . . 1
HOSE, -4 A6/A6 28” . . . . . . . . . . . . 1
ADAP, -12ORM -16JICM STR. . . . . 1
FLOW DIVIDER. . . . . . . . . . . . . . . . 1
ADAP, -6ORM -6JICM STR. . . . . . . 1
TEST PORT. . . . . . . . . . . . . . . . . . . 2
ADAP, -12 ORM -12ORM STR . . . . 1
HYD. PUMP W/STAC VALVE . . . . . 1
PLUG -6ORM . . . . . . . . . . . . . . . . . 1
ADAP, -4ORM -6ORF STR . . . . . . . 1
HOSE, -6 A8/A8 17” . . . . . . . . . . . . 1
CLAMP KIT 2.37” ID . . . . . . . . . . . . 1
ACCUMULATOR, PISTON TYPE . . 1
(315 psi)
2-1/2” T-BOLT BAND CLAMP . . . . . 1
HOSE, -32 MS32/NONE 16” . . . . . 1
SPLIT FLANGE KIT -32 . . . . . . . . . 1
(Includes items 25 , 26 and o-rings)
PLUG -4ORM . . . . . . . . . . . . . . . . . 1
1/2” LOCK WASHER . . . . . . . . . . . . 4
1/2X1-1/2” GR8 BOLT . . . . . . . . . . . 4
ADAP, -8ORM -8JICM R-TEE . . . . . 1
HOSE, -6 A6/A8 46” . . . . . . . . . . . . 1
HOSE, -6 A6/DS8 20” . . . . . . . . . . . 1
HOSE. . . . . . . . . . . . . . . . . . . . . . . . 1
-4, A6/A6 22” (Note b) (shown)
-4, A6/DS6 17” (Note c and d)
ADAP, -4ORM -6JICM STR. . . . . . . 1
HOSE, -6 A8/DS8 88” . . . . . . . . . . . 1
ADAP,. -8JICFS -8JICM R-TEE. . . . 1
ADAP, -10ORM -8JICM STR. . . . . . 1
PUMP GASKET. . . . . . . . . . . . . . . . 1
L69924
L69903
L444012
L69934
L446026
L444008
L70589
Ref.
No.
Part
No.
Description
Qty.
Req.
36
37
38
39
L500348
L500347
L500349
L500430
a
b
Not used when equipped with outriggers.
c
d
Hose is not shown, but has a 90 degree hose end
that connects directly to item #31.
CORE PLUG POPET ASY. . . . . . . . 1
CORE PLUG CAP . . . . . . . . . . . . . . 1
POPET, SPRING . . . . . . . . . . . . . . . 1
POPET. . . . . . . . . . . . . . . . . . . . . . . 1
x
y
Hose Locator
Ref
No.
From Port
To Port
01
05
08
17
22
28
29
30
32
HYDRAULIC PUMP “A”
FLOW DIVIDER “T”
FLOW DIVIDER “PF”
HYDRAULIC PUMP “D”
HYDRAULIC PUMP “E”
HYDRAULIC PUMP “B”
HYDRAULIC PUMP “C”
HYDRAULIC PUMP “B”
MAIN VALVE “IN”
SAHR VALVE “P1”
ACCUMULATOR
HYDRAULIC TANK “SUCTION“
LEVEL VALVE “P”
SAHR VALVE “AI”
LEVEL VALVE “LSP”
STEER MOTOR “P” (IN CAB)
PRINTED IN U.S.A.
247
907878/DP0208
Hydraulics
DL Series Dynalift
Outrigger Hoses on Hydraulic Pump
FRONT
For units equipped with outriggers
11
12
5
6
9
6
7
4
2
3
1
10
13
8
14
907878/DP0208
248
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Outrigger Hoses on Hydraulic Pump
Ref.
No.
01
02
03
04
05
06
07
Part
No.
Description
L64856
L70693
L70694
L69920
L70690
L446049
L62842
Qty.
Req.
ADAP, -16JICFS -16JICM 90 DEG . 2
HOSE, -12 A12/A16 61” . . . . . . . . . 1
HOSE, -12 A12/A16 76” . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 70” . . . . . . . . . . . 1
ADAP, -6 SWIVEL TEE . . . . . . . . . . 2
Ref.
No.
Part
No.
08
09
10
11
12
13
14
L70229
L444002
L444060
L70690
L70493
P471997
L51972
Description
Qty.
Req.
FLOW DIVIDER. . . . . . . . . . . . . . . . 1
ADAP, -6ORM -6JICM STR. . . . . . . 1
ADAP, -12ORM -16JICM STR. . . . . 1
HOSE, -4 A6/DS6 70” . . . . . . . . . . . 1
HOSE, -4 A6/A6 28” . . . . . . . . . . . . 1
TEST PORT. . . . . . . . . . . . . . . . . . . 2
ADAP, -12 ORM -12ORM STR . . . . 1
Hose Locator
Ref
No.
From Port
To Port
02
03
04
05
11
12
HYDRAULIC PUMP
FLOW DIVIDER
FLOW DIVIDER “T”
FLOW DIVIDER “T” SWIVEL
FLOW DIVIDER “PF” SWIVEL
V20 VALVE “PB”
V20 VALVE “IN”
OUTRIGGER PILOT MANIFOLD “T”
OUTRIGGER PILOT MANIFOLD “P”
SAHR VALVE “P1”
PRINTED IN U.S.A.
249
907878/DP0208
Hydraulics
DL Series Dynalift
SAHR and Accumulator Charge Valve
1a
2
FRONT
T
A1
P1
1b
G
Early Models
4
17
3
B
T
7
4
A1
P1
P2
AO
5
16
4
15
6
7
14
8
12
D
13
PUMP
9
10
11
907878/DP0208
250
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
SAHR and Accumulator Charge Valve
Ref.
No.
Part
No.
Description
01
02
03e
03f
04
05
06
07
08
09
10
11
L69395
L71707
L70008
L69919
101317
L444002
L50545
L69926
L69931
L64660
L70267
L445002
L70033
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
SAHR / ACCUM CHARGE VALVE . 1
Note a
Note b (Includes built-in PWP valve)
BRAKE PRESSURE SWITCH . . . . 1
HOSE, -4 A6/A4 62” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 50” . . . . . . . . . . . 1
ADAP, -6ORM -6JICM STR. . . . . . . 4
5/16-18X2-3/4” BOLT . . . . . . . . . . . 2
HOSE, -4 A6/DS6 100” . . . . . . . . . . 1
HOSE, -6 A6/DS8 20” . . . . . . . . . . . 1
HOSE, -6 A8/A8 17” . . . . . . . . . . . . 1
ACCUMULATOR, PISTON TYPE . . 1
(315 psi) Precharged
12
13c
14
15
16c
16d
17
L69930
L71360
101814
L69931
L81233
L444002
L445003
a
b
c
d
e
f
Earlier models
Later models
Used with 4-button joystick
Machines equipped with 26.25 or 26.28 axles.
Machines equipped with 26.48 axles.
HOSE, -4 A6/A6 46” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 98” . . . . . . . . . . . 1
HOSE, -6 A6/A6 25” . . . . . . . . . . . . 1
HOSE, -6 A6/DS8 20” . . . . . . . . . . . 1
ADAP, -6ORM -6JICM STR. . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
03b
03c
06
07
09
12
13*
14
15
SAHR “B”
SAHR “B”
SAHR “AO”
SAHR “A1”
SAHR “P2”
SAHR “P1” (BOTTOM TEE)
SAHR “T”
SAHR “P1”
STEER/BRAKE MANIFOLD “BOTTOM FRONT”
“A” BRAKE PRESSURE INTENSIFIER
BRAKE VALVE “P” (IN CAB)
HYDRAULIC PUMP “BOTTOM TEE”
ACCUMULATOR
JOYSTICK “P”
a PILOT MANIFOLD “P”
a
b
c
*
Use “P” port on upper pilot manifold when unit is equipped with Auxiliary hydraulics
Hose routing for machines equipped with 26.25 or 26.28 axles.
Hose routing for machines equipped with 26.48 axles.
PRINTED IN U.S.A.
251
907878/DP0208
Hydraulics
DL Series Dynalift
SAHR with PWP Valve (Early Models)
(Refer to previous page for SAHR with PWP for Later Models)
3
4
SAHR VALVE
2
T
2
A1
P1
1
5
6
7
2
3
13
1
12
2
9
8
10
2
11
907878/DP0208
252
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
SAHR with PWP Valve (Early Models)
Ref.
No.
Part
No.
01
02
03
04
05
06a
07a
L69903
L445003
L444002
L69395
L446049
L446049
L71360
Description
Qty.
Req.
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
ADAP -6ORM -6JICM STR . . . . . . . 5
SAHR VALVE. . . . . . . . . . . . . . . . . . 1
ADAP -6 SWIVEL TEE . . . . . . . . . . 1
ADAP -6 SWIVEL TEE . . . . . . . . . . 1
HOSE, -4 A6/DS6 98” . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
08
09
10
11
12
13
L69903
L50051
L71733
L70493
L71749
L50364
a
Qty.
Req.
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
1/4-20 FLANGE NUT. . . . . . . . . . . . 2
JOYSTICK DISENGAGE VALVE . . 1
HOSE, -4 A6/A6 28” . . . . . . . . . . . . 1
VALVE MOUNT BRACKET . . . . . . . 1
1/4-20X1-1/2” BOLT . . . . . . . . . . . . 2
Hose Locator
Ref
No.
From Port
To Port
01
07c
08
11
PWP VALVE PORT “3”
SAHR VALVE “P1” (BOTTOM OF TEE)
SAHR - SWIVEL TEE ON PORT “T”
PILOT APPLY MANIFOLD “P”
SAHR - “P1”
HYDRAULIC PUMP/FLOW DIVIDER “PF”
c
Used only with 4-button joystick.
PRINTED IN U.S.A.
253
907878/DP0208
Hydraulics
DL Series Dynalift
Steer Select Valve
FRONT
4
3
6
5
T
B
2
A
1
P
8
7
2
907878/DP0208
254
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Steer Select Valve
Ref.
No.
01
02
03
04
Part
No.
Description
L69747
L445003
L69937
L50535
Qty.
Req.
STEER SELECT VALVE . . . . . . . . . 1
HOSE -6 A6/DS6 100”. . . . . . . . . . . 1
1/4-20X3” BOLT. . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
05
06
07
08
L444002
L69939
L69935
L50051
Description
Qty.
Req.
ADAP -6ORM -6JICM STR . . . . . . . 2
HOSE -6 A8/DS6 20”. . . . . . . . . . . . 2
HOSE -6 A8/A6 108” . . . . . . . . . . . . 1
1/4-20 NUT . . . . . . . . . . . . . . . . . . . 2
Hose Locator
Ref
No.
From Port
03
06
06
07
STEER
STEER
STEER
STEER
PRINTED IN U.S.A.
SELECT VALVE
SELECT VALVE
SELECT VALVE
SELECT VALVE
To Port
“T”
“B”
“A”
“P”
STEER/BRAKE MANIFOLD “TOP LEFT SIDE”
STEER CYLINDER (REAR AXLE-LEFT SIDE)
STEER CYLINDER (REAR AXLE-RIGHT SIDE)
STEER MOTOR “L” (IN CAB)
255
907878/DP0208
Hydraulics
DL Series Dynalift
Steer/Brake Lines Manifolds
(26.25 and 26.28 Axles)
3
PWP (OPTION)
FRONT
4
2
1
5
DECLUTCH
4
7
6
8
9
11
10
4
12
11
11
15
4
5
10
4
14
16
15
907878/DP0208
13
256
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(26.25 and 26.28 Axles)
Ref.
No.
Part
No.
01
02
03a
03b
04
05
06
07
08
09
L70415
L70428
L70415
L60986
L444005
L69942
L50051
L50876
L69929
L69937
Description
Qty.
Req.
PRESSURE SWITCH (Declutch) . . 1
BRAKE LINES MANIFOLD . . . . . . . 1
PRESSURE SWITCH (PWP). . . . . 1
ADAP, -4ORM PLUG. . . . . . . . . . . . 1
ADAP, -4ORM -4JICM STR. . . . . . . 8
HOSE, -4 A4/A4 72” . . . . . . . . . . . . 1
1/4-20 FLANGE NUT. . . . . . . . . . . . 2
1/4-20X2-1/4” STUD . . . . . . . . . . . . 2
HOSE, -4 A6/A4 102” . . . . . . . . . . . 1
HOSE, -6 A6/DS6 100” . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
10
11
12
13
14
15
16
L69940
L444002
L70514
L69936
L50835
L69939
L69919
a
b
When equipped with PWP
When not equipped with PWP
Qty.
Req.
HOSE, -4 A4/NS4 20” . . . . . . . . . . . 4
ADAP, -6ORM -6JICM STR. . . . . . . 4
STEER/BRAKE BLOCK . . . . . . . . . 1
HOSE, -6 A8/DS6 100” . . . . . . . . . . 1
5/16-18X2” BOLT. . . . . . . . . . . . . . . 2
HOSE, -6 A8/DS6 20” . . . . . . . . . . . 2
HOSE, -4 A6/A4 62” . . . . . . . . . . . . 1
Hose Locator
Ref
No.
05
08
09
10
13
15
16
From Port
To Port
BRAKE LINES MANIFOLD (SIDE)
BRAKE LINES MANIFOLD (LOWER)
STEER/BRAKE MANIFOLD (UPPER LEFT SIDE)
STEER/BRAKE MANIFOLD (TOP/SIDE PORTS)
STEER/BRAKE MANFLD. (BOTTOM/SIDE PORTS)
STEER/BRAKE MANIFOLD (UPPER RIGHT SIDE)
STEER/BRAKE MANIFOLD (UPPER FRONT)
STEER/BRAKE MANIFOLD (LOWER FRONT)
STEER/BRAKE MANIFOLD “CENTER FRONT”
BRAKE VALVE “B” (IN CAB)
STEER SELECT VALVE “T”
FRONT AXLE BRAKE TOP PORTS
FRONT AXLE BRAKE BOTTOM PORTS
STEER MOTOR “R” (IN CAB)
STEER CYLINDER (FRONT AXLE BOTH SIDES)
SAHR VALVE “B”
PRINTED IN U.S.A.
257
907878/DP0208
Hydraulics
DL Series Dynalift
(26.48 Axles)
FRONT
3
PWP (OPTION)
18
4
2
5
1
6
DECLUTCH
17
4
7
8
9
11
10
4
12
11
11
16
15
4
5
10
4
16
14
16
15
907878/DP0208
13
258
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(26.48 Axles)
Ref.
No.
Part
No.
01
02
03a
03b
04
05
06
07
08
09
10
L70415
L70428
L70415
L60986
L444005
L69942
L50051
L50876
L69929
L69937
L69940
Description
Qty.
Req.
PRESSURE SWITCH (Declutch) . . 1
BRAKE LINES MANIFOLD . . . . . . . 1
PRESSURE SWITCH (PWP). . . . . 1
ADAP, -4ORM PLUG. . . . . . . . . . . . 1
ADAP, -4ORM -4JICM STR. . . . . . . 5
HOSE, -4 A4/A4 72” . . . . . . . . . . . . 1
1/4-20 FLANGE NUT. . . . . . . . . . . . 2
1/4-20X2-1/4” STUD . . . . . . . . . . . . 2
HOSE, -4 A6/A4 102” . . . . . . . . . . . 1
HOSE, -6 A6/DS6 100” . . . . . . . . . . 1
HOSE, -4 A4/NS4 20” . . . . . . . . . . . 2
Ref.
No.
Part
No.
Description
11
12
13
14
15
16
17
18
L444002
L70514
L69936
L50835
L69939
L60986
101320
L446044
a
b
When equipped with PWP
When not equipped with PWP
Qty.
Req.
ADAP, -6ORM -6JICM STR. . . . . . . 4
STEER/BRAKE BLOCK . . . . . . . . . 1
HOSE, -6 A8/DS6 100” . . . . . . . . . . 1
5/16-18X2” BOLT. . . . . . . . . . . . . . . 2
HOSE, -6 A8/DS6 20” . . . . . . . . . . . 2
PLUG, -4 ORM. . . . . . . . . . . . . . . . . 3
HOSE, -4 A4/A4 45” . . . . . . . . . . . . 1
ADP, -4 SWIVEL TEE . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
05
08
09
10
13
15
17
BRAKE LINES MANIFOLD (SIDE)
BRAKE LINES MANIFOLD (LOWER)
STEER/BRAKE MANIFOLD (UPPER LEFT SIDE)
STEER/BRAKE MANIFOLD (UPPER RIGHT SIDE)
STEER/BRAKE MANIFOLD (UPPER FRONT)
BRAKE LINES MANIFOLD TEE
STEER/BRAKE MANIFOLD “CENTER FRONT”
BRAKE VALVE “B” (IN CAB)
STEER SELECT VALVE “T”
FRONT AXLE BRAKE TOP PORTS
STEER MOTOR “R” (IN CAB)
STEER CYLINDER (FRONT AXLE BOTH SIDES)
BULKHEAD TEE ABOVE REAR AXLE
PRINTED IN U.S.A.
259
907878/DP0208
Hydraulics
DL Series Dynalift
Park Brake Intensifier
(26.48 Axles)
2
1
B
3
4
5
6
7
8
9
A
10
11
907878/DP0208
260
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Park Brake Intensifier
(26.48 Axles)
Ref.
No.
01
02
03
04
05
06
Part
No.
Description
101692
L62842
101383
650490
654049
654026
Qty.
Req.
HOSE -6 A6/DS6 104”. . . . . . . . . . . 1
ADAP -4ORM -6JICM STR . . . . . . . 1
PARK BRAKE INTENSIFIER . . . . . 1
3/8”X1” BOLT. . . . . . . . . . . . . . . . . . 4
3/8” FLAT WASHER . . . . . . . . . . . . 4
3/8” LOCK WASHER . . . . . . . . . . . . 4
Ref.
No.
Part
No.
07
08
09
10
11
650488
101383
067847
L445003
101317
Description
Qty.
Req.
3/8”X3/4” BOLT . . . . . . . . . . . . . . . . 4
MOUNT BRACKET . . . . . . . . . . . . . 1
3/8” NYLON INSERT NUT . . . . . . . 4
ADAP., -6ORM -6JICM 90O . . . . . . . 1
HOSE, -4 A6/DS6 50” . . . . . . . . . . . 1
Hose Locator
Ref
No.
01
11
From Port
To Port
PARK BRAKE INTENSIFIER “B”
PARK BRAKE INTENSIFIER “A”
FRONT AXLE PARK BRAKE CALIPER
SAHR VALVE “B”
PRINTED IN U.S.A.
261
907878/DP0208
Hydraulics
DL Series Dynalift
Axle Steer and Brake Lines
(26.25 and 26.28 Axles)
FRONT
3
FRONT AXLE
4
1
3
2
5
5
4
REAR AXLE
FRONT
1
2
6
6
907878/DP0208
262
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(26.25 and 26.28 Axles)
Ref.
No.
01
02
03
Part
No.
Description
L69576
L446024
L69577
Qty.
Req.
ADAP M18X1.5ORM - 8JICM STR . 4
ADAP -8JICFS -8JICM SWVL 45 . . 4
ADAP M10X1ORM -4JICM STR . . . 4
Ref.
No.
Part
No.
04
05
06
L69940
L69939
L69939
Description
Qty.
Req.
HOSE -4 A4/NS4 20”. . . . . . . . . . . . 4
HOSE -6 A8/DS6 20”. . . . . . . . . . . . 2
HOSE -6 A8/DS6 20”. . . . . . . . . . . . 2
Hose Locator
Ref
No.
04
05
06
06
From Port
To Port
FRONT AXLE TOP BRAKE PORTS
FRONT AXLE BOTTOM BRAKE PORTS
STEER CYLINDER FRONT AXLE BOTH SIDES
STEER CYLINDER REAR AXLE (LEFT SIDE)
STEER CYLINDER REAR AXLE (RIGHT SIDE)
STEER/BRAKE MANFLD. (BOTTOM/SIDE PORTS)
STEER/BRAKE MANIFOLD (TOP FRONT PORTS)
STEER SELECT VALVE “B”
STEER SELECT VALVE “A”
PRINTED IN U.S.A.
263
907878/DP0208
Hydraulics
DL Series Dynalift
(26.48 Axles)
FRONT
4
1
4
2
1
7
FRONT AXLE
2
6
7
3
1
5
5
2
1
REAR AXLE
8
9
10
2
FRONT
907878/DP0208
8
264
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(26.48 Axles)
Ref.
No.
Part
No.
01
02
03
04
05
06a
07
08
L444004
L65753
L62842
101319
101319
101692
L69940
L69940
Description
Qty.
Req.
ADP/-8ORM-8JICM STR. . . . . . . . . 4
ADP, -6ORM -4JICM STR . . . . . . . . 4
ADP -4ORM-6JICM 90 . . . . . . . . . . 1
HOSE -6 A6/NS8 40”. . . . . . . . . . . . 2
HOSE -6 A6/NS8 40”. . . . . . . . . . . . 2
HOSE -6 A6/DS6 104”. . . . . . . . . . . 1
HOSE -4 A4/NS4 108”. . . . . . . . . . . 2
HOSE -4 A4/NS4 108”. . . . . . . . . . . 2
Ref.
No.
Part
No.
Description
Qty.
Req.
09
10
L446042
101320
a
Some early units with the 26.48 axles used a
smaller hose -4 (1/4”). If your unit currently has
this smaller hose, you should order PN 430177
Hose kit which includes hose PN #101692 and
(2) L62842 adapters (item #3)
TEE, BULKHEAD -4JICM . . . . . . . . 1
HOSE, -4 A4/A4 45” . . . . . . . . . . . . 1
Hose Locator
Ref
No.
04
05
06
07
08
10
From Port
To Port
STEER CYLINDER FRONT AXLE BOTH SIDES
STEER CYLINDER REAR AXLE (LEFT SIDE)
STEER CYLINDER REAR AXLE (RIGHT SIDE)
FRONT AXLE PARK BRAKE CALIPER
FRONT AXLE BRAKE PORTS (BOTH SIDES)
REAR AXLE BRAKE PORTS (BOTH SIDES)
STEER/BRAKE MANIFOLD (TOP FRONT PORTS)
STEER SELECT VALVE “B”
STEER SELECT VALVE “A”
HYDRAULIC PRESSURE INTENSIFIER
STEER/BRAKE MANIFOLD (MIDDLE/SIDE PORTS)
TEE ON THE BRAKE LINES MANIFOLD
265
907878/DP0208
PRINTED IN U.S.A.
Hydraulics
DL Series Dynalift
Brake Valve
4
2
5
3
T
P
6
2
B
1
Ref.
No.
01
02
03
Part
No.
L69572
L445003
L444002
Description
Qty.
Req.
BRAKE MODULATING VALVE . . . . 1
ADAP -6ORM -6JICM STR . . . . . . . 1
Ref.
No.
Part
No.
04
05
06
L69926
L69927
L69929
Description
Qty.
Req.
HOSE -4 A6/DS6 100”. . . . . . . . . . . 1
HOSE -4 A6/A6 81” . . . . . . . . . . . . . 1
HOSE -4 A6/A4 102” . . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
04
05
06
BRAKE VALVE “P”
BRAKE VALVE “T”
BRAKE VALVE “B”
SAHR VALVE “AO”
BRAKE MANIFOLD (BOTTOM PORT)
907878/DP0208
266
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Steer Motor
2
4
1
3
LS
L
5
T
R
P
6
7
8
10
Ref.
No.
Part
No.
Description
01a
02
03
04
05
06
07
08
09
10
9
Qty.
Req.
STEER MOTOR ASY. . . . . . . . . . . . 1
Note b
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Note c
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
ADAP --80RM -8JICM 45 ELBOW . 3
HOSE -4 A4/A6 100” . . . . . . . . . . . . 1
HOSE -6 A8/A6 108” . . . . . . . . . . . . 1
HOSE -6 A8/A6 100” . . . . . . . . . . . . 1
HOSE -6 A8/A6 60” . . . . . . . . . . . . . 1
HOSE -6 A8/DS8 88”. . . . . . . . . . . . 1
ADAP -8JICFS -8JICM SWVL. . . . . 1
CHECK VALVE . . . . . . . . . . . . . . . . 1
101881
L500968
L69128
L99930
L51591
L445013
L69925
L69935
L69936
L69933
L69934
L446024
L64524
Ref.
No.
a
b
c
Part
No.
Description
Qty.
Req.
Field replacement of parts other than seals is
not recommended.
HOSE LOCATOR
04
05
06
07
08
STEER
STEER
STEER
STEER
STEER
PRINTED IN U.S.A.
MOTOR
MOTOR
MOTOR
MOTOR
MOTOR
“LS” (IN CAB)
“L” (IN CAB)
“R” (IN CAB)
“T” (IN CAB)
“P” (IN CAB)
LEVEL VALVE “LSB”
STEER SELECT VALVE “P”
STEER/BRAKE MANIFOLD (TOP RIGHT SIDE)
HYDRAULIC PUMP (Ref item #32 on Hyd. Pump)
267
907878/DP0208
Hydraulics
DL Series Dynalift
Level Valve
FRONT
2
3
12
1
A2
3
4
A1
B2
11
LSB
P
B1
LSP
10
5
T
3
3
9
6
7
8
2
907878/DP0208
268
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Level Valve
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
Part
No.
Description
L70230
L50556
L444002
L69921
Qty.
Req.
LEVEL VALVE, COMPLETE . . . . . . 1
5/16-18 NUT . . . . . . . . . . . . . . . . . . 5
ADAP -6ORM -6JICM STR . . . . . . . 7
HOSE, -4 A6/A6 126” . . . . . . . . . . . 2
HOSE. . . . . . . . . . . . . . . . . . . . . . . . 1
-4, A6/A6 22” (Note a)
-4, A6/DS6 17” (Note b)
HOSE, -4 A6/DS6 100” . . . . . . . . . . 1
5/16-18X4” STUD . . . . . . . . . . . . . . 2
HOSE, -6 A6/A6 50” . . . . . . . . . . . . 1
HOSE, -6 A6/A8 46” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 65” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 65” . . . . . . . . . . . 1
L69924
L69903
L69925
L445003
L50679
L69922
L69932
L70084
L70084
Ref.
No.
Part
No.
Description
a
b
Qty.
Req.
Hose Locator
Ref
No.
From Port
04
04
05
06
09
10
11
12
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
LEVEL VALVE
PRINTED IN U.S.A.
To Port
“A1”
“B1”
“LSP”
“LSB”
“T”
“P”
“B2”
“A2”
LEVEL CYLINDER (OUTSIDE FITTING)
LEVEL CYLINDER (CAB SIDE FITTING)
HYDRAULIC PUMP “C” (Refer to HYD. PUMP)
STEER MOTOR “LS” (IN CAB)
HYDRAULIC PUMP “B” (Refer to HYD. PUMP)
STABILIZER CYLINDER MANIFOLD “M” (REAR)
STABILIZER CYLINDER MANIFOLD “L” (FRONT)
269
907878/DP0208
Hydraulics
DL Series Dynalift
Main Control Valve Group
12
NOTE: The (optional) auxiliary
hydraulics valve section is
shown in this illustration.
16
To Hydraulic
Oil Cooler
13
14
20
11
14
17
15
20
22
18
17
18
19
21
To Lift
Cylinder
Tubes
10
19
20
To Lift
Cylinder
Tubes
23
To Slave
Cylinder
Tubes
8
9
7
To
Hydraulic
Pump
24
1
AUXILIARY - SECTION
2
BOOM IN/OUT - SECTION
TILT - SECTION
FRONT
LIFT - SECTION
3
4
5
907878/DP0208
270
6
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01a
105159
02
03
04
05
06
07
L50277
L50147
L50283
L50151
103899
103194
08
09
10
11
12
13
14b
15
16
17
L69908
L446020
P471299
L446034
105167
L51590
103902
103901
105164
103900
Description
Qty.
Req.
MAIN CONTROL VALVE . . . . . . . . . 1
(does not include auxiliary section)
3/8”-16X3-1/2” BOLT . . . . . . . . . . . . 2
3/8” LOCK WASHER . . . . . . . . . . . . 2
1/2-13X1-1/4” BOLT . . . . . . . . . . . . 2
1/2” FLAT WASHER . . . . . . . . . . . . 2
VALVE MOUNT PLATE . . . . . . . . . . 1
ADAPTER, JOYSTICK . . . . . . . . . AR
(1/4BSP -6JICM STR)
HOSE, -8 A12/DS10 50” . . . . . . . . . 2
ADAP. -12JICM -12JICFS 900 . . . . . 2
ADAP -12JICM BLKHD RUN TEE . 2
ADAP -12JICM BLKHD 90 . . . . . . AR
HOSE, -16 A16/DS16 78” . . . . . . . . 1
ADAP. -16JICM -16ORM STR. . . . . 1
TUBE, AUXILIARY SECT. . . . . . . . . 2
TUBE, BOOM IN/OUT (LONG) . . . . 1
TUBE, BOOM IN/OUT (SHORT). . . 1
TUBE, TILT SECTION . . . . . . . . . . . 2
Ref.
No.
Part
No.
Description
Qty.
Req.
18
19
20
21
22
23
24
L445090
L69913
L444001
105161
L99903
L51621
105166
a
The standard valve does not include the auxiliary
hydraulics valve section. To add the auxiliary
hydraulics section order PN 105165 Valve Section
and (4) PN 103059 Tie Rod Kit.
b
Used when equipped with optional auxiliary
hydraulics valve section.
ADAP. -12JICM -12ORM 900 LNG . 2
HOSE, -12 A12/DS10 36” . . . . . . . . 2
ADAP -12ORM -12JICM STR . . . AR
ADAPTER, PORT RESTRICTOR . . 1
RESTRICTOR, WORK PORT . . . . . 1
ADAP. -16JICM -16ORM 900 . . . . . 1
HOSE, -16 A16/A16 62” . . . . . . . . . 1
Usage Table
PRINTED IN U.S.A.
271
907878/DP0208
Hydraulics
DL Series Dynalift
15
14
NOTE: The (optional) auxiliary
hydraulics valve section is
shown in this illustration.
13
12
15
11
11
12
13
14
9
10
2
16
8
17
OUT
IN
1
AUXILIARY
BOOM EXTEND
7
LIFT
TILT
3
6
4
5
FRONT
907878/DP0208
272
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01
L69475
02
L444002
03
04
05
06
07
08
09
10
11
12
13a
L71454
L50283
L50151
L50141
L50561
L51590
L445090
L444001
L69733
L69732
L69731
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
MAIN CONTROL VALVE . . . . . . . . . 1
(does not include auxiliary section)
ADAPTER, JOYSTICK . . . . . . . . . . 8
(-6ORM -6JICM STR)
VALVE MOUNT PLATE . . . . . . . . . . 1
1/2-13X1-1/4” BOLT . . . . . . . . . . . . 2
1/2” FLAT WASHER . . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . . 3
5/16-18X1-3/4” BOLT . . . . . . . . . . . 3
ADAP -12ORM -12JICM 90 LNG . . 2
TUBE,. TILT . . . . . . . . . . . . . . . . . . . 2
TUBE, BOOM EXTEND . . . . . . . . . 2
TUBE, HYDRAULIC OPTION . . . . . 2
14
15
16
17a
P471299
L446034
L446020
L66576
a
For units equipped with Auxiliary hydraulics.
Refer to Hydraulic Components section for more
information.
ADAP -12JICM BLKHD 90 . . . . . . . 4
ADAP -12JIFS -12JICM 90 . . . . . . . 2
AUXILIARY VALVE SECTION. . . . . 1
Usage Table
PRINTED IN U.S.A.
273
907878/DP0208
Hydraulics
DL Series Dynalift
Tri-Function Pilot Manifold (Standard Hydraulics)
(Four-Button Joystick)
FRONT
1
9
2
SAHR VALVE “P1”
3
11
8
HYDRAULIC TANK
Main Valve
(Early Style Shown)
9
10
P
6
A
8
4
T
B
4
5
STANDARD
7
3
907878/DP0208
274
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Tri-Function Pilot Manifold (Standard Hydraulics)
Ref.
No.
01
02
03
04
05
06
Part
No.
Description
L70014
L69907
L69920
L444002
L69904
L71339
Qty.
Req.
ADAP -6JICM BLKHEAD TEE . . . . 1
HOSE, --4 A6/DS6 84” . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
ADAP -6ORM -6JICM STR . . . . . AR
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 2
PILOT APPLY MANIFOLD. . . . . . . . 1
Ref.
No.
Part
No.
07
08
09
10
11
L445003
L69904
L71360
L50741
L447034
Description
Qty.
Req.
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 2
HOSE, -4 A6/DS6 98” . . . . . . . . . . . 1
1/4”X3-1/4” STUD . . . . . . . . . . . . . . 2
ADAP CAP -6JICF. . . . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
02
03
05
08
09
BULKHEAD TEE (ABOVE V40 VALVE)
PILOT APPLY MANIFOLD “T”
PILOT APPLY MANIFOLD “B”
PILOT APPLY MANIFOLD “A”
PILOT APPLY MANIFOLD “P”
V40 PILOT VALVE (as shown)
PRINTED IN U.S.A.
275
907878/DP0208
Hydraulics
DL Series Dynalift
Tri-Function Pilot Manifold (w/Auxiliary Hydraulics)
FRONT
1
2
SAHR VALVE “P1”
3
14
15
9
HYDRAULIC TANK
11
14
Main Valve
(Early Style Shown)
7
13
10
5
P
A
6
11
12
T
4
B
5
10
Auxiliary
8
15
P
A
9
6
T
4
B
7
STANDARD
8
3
907878/DP0208
276
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Tri-Function Pilot Manifold (w/Auxiliary Hydraulics)
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
Description
L70014
L69907
L69920
L444002
L69903
L71339
L69904
L60653
Qty.
Req.
HOSE, -4 A6/DS6 84” . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
ADAP -6JICFS -6JICM 90 . . . . . . . 2
Ref.
No.
Part
No.
09
10
11
12
13
14
15
L69904
L69903
L69903
L81233
L50745
L71360
L69920
Description
Qty.
Req.
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
ADAP -6ORM -6JICM RUN TEE. . . 1
1/4”-20X5-3/4” STUD. . . . . . . . . . . . 2
HOSE, -4 A6/DS6 98” . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
02
03
05
07
09
10
11
14
15
STANDARD PILOT APPLY MANIFOLD “T”
AUXILIARY PILOT APPLY MANIFOLD “B”
STANDARD PILOT APPLY MANIFOLD “B”
STANDARD PILOT APPLY MANIFOLD “A”
STANDARD PILOT APPLY MANIFOLD “P”
Auxiliary PILOT APPLY MANIFOLD “A”
Auxiliary PILOT APPLY MANIFOLD “P”
Auxiliary PILOT APPLY MANIFOLD “T”
Auxiliary PILOT APPLY MANIFOLD “P”
PRINTED IN U.S.A.
277
907878/DP0208
Hydraulics
DL Series Dynalift
Tri-Function Pilot Manifold - Radio Remote Option
SAHR Valve
P2
1
3
2
4
E2
E3
E4
E1
JS
6
P
J2
J1
5
T
7
J3
12
11
J4
8
10
T
13
6
9
14
BOOM IN/OUT
TILT
BOOM UP/DOWN
15
FRONT
907878/DP0208
15
278
14
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Tri-Function Pilot Manifold - Radio Remote Option
Ref.
No.
01
02
03
04
05
06
07
08
09
10
Part
No.
103506
103505
L60653
L444012
L62842
L68804
103413
L445003
103425
L444002
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
HOSE, -4 A6/DS6 106” . . . . . . . . . . 1
HOSE, -4 DS6/H6 109” . . . . . . . . . . 1
ADAP., -6JICFS -6JICM 90O . . . . . . 4
ADAP., -4ORM -6JICM STR.. . . . . . 5
ADAP., -4ORM -6JICM 90O . . . . . . 6
HOSE, -4 A6/DS6 26” . . . . . . . . . . . 4
MANIFOLD, RADIO REMOTE . . . . 1
ADAP., -6ORM -6JICM 90O . . . . . . . 1
MOUNT, MANIFOLD . . . . . . . . . . . . 1
ADAP., -6ORM -6JICM STR. . . . . AR
11
12
13a
14
15
L446049
L69903
L71339
L69902
L69906
a
Units equipped with auxiliary hydraulics will use two
manifolds. The house routing will be the same as
shown in the illustration.
279
Description
Qty.
Req.
ADAP., -6 RUN TEE . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
PILOT APPLY MANIFOLD . . . . . . AR
HOSE, -4 H6/A6 20” . . . . . . . . . . . . 4
HOSE, -4 A6/A6 110” . . . . . . . . . . . 4
907878/DP0208
Hydraulics
DL Series Dynalift
Dual-Function Pilot Manifold (Standard Hydraulics)
(Two-Button Joystick)
FRONT
14
3
4
2
17
6
5
16
11
17
Main Valve
(Later Style Shown)
8
1
16
3
9
STANDARD
10
A
15
T1
T2
B
8
2
4
13
9
14
907878/DP0208
1
12
280
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Dual-Function Pilot Manifold (Standard Hydraulics)
Ref.
No.
Part
No.
01
02a
03
04
05a
06
07
08
09
10
11
L445003
L69906
L70014
L447034
L69906
L69907
L444002
L69904
L69903
L69467
L50743
L50051
L69905
12a
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
ADAP -6ORM -6JICM 90 . . . . . . . AR
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
ADAP, -6JICM CAP . . . . . . . . . . . . . 1
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 84” . . . . . . . . . . . 1
ADAP -6ORM -6JICM STR . . . . . . . 7
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
STUD . . . . . . . . . . . . . . . . . . . . . . . . 2
1/4”-20 WHIZ LOCK NUT . . . . . . . . 2
HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
13
14
15a
16
17
L446048
L69920
L69905
L69903
L69904
a
Hoses come from the dual-function controller
(joystick). Refer to “Dual-Function Controller” for
more information.
ADAP, -6ORM PLUG. . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
02
05
06
08
09
12
14
15
16
17
PILOT VALVE (as shown)
BULKHEAD TEE (ABOVE VALVE)
STANDARD PILOT APPLY MANIFOLD
JOYSTICK “4”
JOYSTICK “2”
JOYSTICK “1”
BULKHEAD TEE (ABOVE VALVE)
JOYSTICK “3”
PRINTED IN U.S.A.
“2”
“4”
“B”
“T2”
“A”
“3”
“3”
281
907878/DP0208
Hydraulics
DL Series Dynalift
Dual-Function Pilot Manifold - Radio Remote Option
(Without Auxiliary Hydraulic Option)
FRONT
SAHR Valve
P2
1
12
2
11
E3
E2
E4
E1
JS
5
P
J2
J1
10
T
J3
14
3
J4
5
T1
4
8
9
6
7
4
Main Valve
(Early Style Shown)
BOOM IN/OUT
TILT
6
BOOM UP/DOWN
13
13
FRONT
907878/DP0208
282
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Dual-Function Pilot Manifold - Radio Remote Option
(Without Auxiliary Hydraulic Option)
Ref.
No.
01
02
03
04
05
06
07
Part
No.
103506
103505
L69903
L70688
L68804
L69902
L69467
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE, -4 A6/DS6 106” . . . . . . . . . . 1
HOSE, -4 DS6/H6 109” . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/A6 16” . . . . . . . . . . . . 2
HOSE, -4 A6/DS6 26” . . . . . . . . . . . 4
HOSE, -4 H6/A6 20” . . . . . . . . . . . . 2
Ref.
No.
Part
No.
08
09
10
11
12
13
14
L444002
103425
L62842
L444012
L60653
L69905
103413
283
Description
Qty.
Req.
MOUNT, MANIFOLD . . . . . . . . . . . . 1
ADAP., -4ORM -6JICM 90O . . . . . . 6
ADAP., -4ORM -6JICM STR.. . . . . . 5
ADAP., -6JICFS -6JICM 90O . . . . . . 4
HOSE, -4 A6/A6 130” . . . . . . . . . . . 2
907878/DP0208
Hydraulics
DL Series Dynalift
Dual-Function Pilot Manifold (w/AUXILIARY Hydraulics)
1
2
Main Valve
(Early Style Shown)
21
4
1
20
5
3
19
A
T1
Auxiliary
T2
18
B
6
2
4
8
1
17
16
3
A
9
T1
T2
7
B
2
4
STANDARD
10
15
14
13
12
907878/DP0208
11
284
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Dual-Function Pilot Manifold (w/Auxiliary Hydraulics)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
Description
L70014
L69907
L444002
L50744
L69467
L69903
L69904
L69902
L69906
L69920
L69904
L69903
Qty.
Req.
HOSE, -4 A6/DS6 84” . . . . . . . . . . . 1
STUD . . . . . . . . . . . . . . . . . . . . . . . . 2
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/H6 20” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
Ref.
No.
Part
No.
12
13
14
15
16
17
18
19
L69905
L446048
L445003
L69920
L69905
L69903
L69904
L69902
L69906
L69904
L69903
20
21
Description
Qty.
Req.
HOSE, -4 A6/DS6 130” . . . . . . . . . . 1
ADAP, -6ORM PLUG. . . . . . . . . . . . 1
ADAP -6ORM -6JICM 90. . . . . . . . . 6
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 130” . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/H6 20” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 20” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
02
06
07
08
09
10
11
12
15
16
17
18
19
20
21
AUXILIARY PILOT APPLY MANIFOLD “2”
Auxiliary PILOT APPLY MANIFOLD “B”
Auxiliary PILOT APPLY MANIFOLD “T1”
STANDARD PILOT APPLY MANIFOLD “2”
STANDARD PILOT APPLY MANIFOLD “T2”
JOYSTICK “2”
JOYSTICK “1”
JOYSTICK “3”
JOYSTICK “4”
PRINTED IN U.S.A.
285
907878/DP0208
Hydraulics
DL Series Dynalift
Dual-Function Pilot Manifold (Radio Remote Option)
(With Auxiliary Hydraulic Option)
FRONT
SAHR Valve
P2
1
8
2
11
E3
E2
E4
JS
E1
4
P
J2
J1
7
T
6
3
J3
5
J4
12
T1
9
4
10
3
Main Valve
(Early Style Shown)
4
BOOM IN/OUT
TILT
BOOM UP/DOWN
907878/DP0208
286
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Dual-Function Pilot Manifold (Radio Remote Option)
(With Auxiliary Hydraulic Option)
Ref.
No.
01
02
03
04
05
06
Part
No.
103506
103505
L70688
L68804
L69903
103413
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE, -4 A6/DS6 106” . . . . . . . . . . 1
HOSE, -4 DS6/H6 109” . . . . . . . . . . 1
HOSE, -4 A6/A6 16” . . . . . . . . . . . . 4
HOSE, -4 A6/DS6 26” . . . . . . . . . . . 4
HOSE, -4 A6/DS6 17” . . . . . . . . . . . 1
Ref.
No.
Part
No.
07
08
09
10
11
12
L62842
L60653
L444002
103425
L444012
L69467
287
Description
Qty.
Req.
ADAP., -4ORM -6JICM 90O . . . . . . 6
ADAP., -6JICFS -6JICM 90O . . . . . . 4
MOUNT, MANIFOLD . . . . . . . . . . . . 1
ADAP., -4ORM -6JICM STR.. . . . . . 5
907878/DP0208
Hydraulics
DL Series Dynalift
V20 Valve (Outriggers)
1
FRONT
OUT
IN
4
2
2
3
3
1
PB
12
2
5
11
8
10
7
6
9
907878/DP0208
4
288
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
V20 Valve (Outriggers)
Ref.
No.
01
02
03
04
05
06
Part
No.
Description
L70528
L445001
L70694
L70692
L445090
L443022
Qty.
Req.
V20 VALVE . . . . . . . . . . . . . . . . . . . 1
ADAP -12ORM -12JICM 90 . . . . . . 2
HOSE -12 A12/A16 76” . . . . . . . . . 1
HOSE -12 A12/NS10 51” . . . . . . . . 1
ADAP -8ORM -8JICM 90 LNG . . . . 2
Ref.
No.
Part
No.
Description
07
08
09
10
11
12
L445002
L70691
L70691
L70695
L70695
L70693
Qty.
Req.
ADAP -8ORM -8JICM 90. . . . . . . . . 2
HOSE -6 A8/DS8 70”. . . . . . . . . . . . 1
HOSE -6 A8/DS8 70”. . . . . . . . . . . . 1
HOSE -6 A8/DS8 68”. . . . . . . . . . . . 1
HOSE -6 A8/DS8 68”. . . . . . . . . . . . 1
HOSE -12 A12/A16 61 . . . . . . . . . . 1
2
3
1
Outrigger Cylinder
Right Side
4
Outrigger Cylinder
Left Side
FRONT
Hose Locator
Ref
No.
From Port
03
04
08
09
10
11
12
V20
V20
V20
V20
V20
V20
V20
PRINTED IN U.S.A.
VALVE
VALVE
VALVE
VALVE
VALVE
VALVE
VALVE
To Port
“IN”
“OUT”
“3”
“1”
“2”
“4”
“PB”
FLOW DIVIDER ON HYDRAULIC PUMP
HYDRAULIC TANK
LEFT OUTRIGGER “UPPER PORT” (3)
RIGHT OUTRIGGER “LOWER PORT” (1)
RIGHT OUTRIGGER “UPPER PORT” (2)
LEFT OUTRIGGER “LOWER PORT” (4)
HYDRAULIC PUMP
289
907878/DP0208
Hydraulics
DL Series Dynalift
Outrigger Pilot Manifold
4
V20 VALVE
2
4
1
13
3
12
4
10
9
11
P
T
8
7
P
1
2
4
3
6
1
FRONT
T
1
2
5
3
3
2
4
4
907878/DP0208
290
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Outrigger Pilot Manifold
Ref.
No.
01
02
03
04
05
06
07
Part
No.
Description
103878
L50743
L50051
L445003
L70689
L70688
L70689
Qty.
Req.
OUTRIGGER PILOT VALVE . . . . . . 1
1/4”-20X3” STUD. . . . . . . . . . . . . . . 2
1/4”-20 FLANGE NUT . . . . . . . . . . . 2
ADAP -6ORM - 6JICM 90 . . . . . . . . 8
HOSE, -4 A6/A6 28” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 16” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 28” . . . . . . . . . . . . 1
Ref.
No.
Part
No.
08
09
10
11
12
13
L70688
L70690
L70690
L444002
L520004
L50878
Description
Qty.
Req.
HOSE, -4 A6/A6 16” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 70” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 70” . . . . . . . . . . . 1
ADAP -6ORM -6JICM STR . . . . . . 11
5/16”-18X3” STUD. . . . . . . . . . . . . . 3
Hose Locator
Ref
No.
From Port
05
06
07
08
09
10
OUTRIGGER
OUTRIGGER
OUTRIGGER
OUTRIGGER
OUTRIGGER
OUTRIGGER
PRINTED IN U.S.A.
To Port
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
PILOT MANIFOLD
“4”
“3”
“2”
“1”
“T”
“P”
V20 VALVE “4”
V20 VALVE “3”
V20 VALVE “2”
V20 VALVE “1”
HYDRAULIC PUMP FLOW DIVIDER “T”
HYDRAULIC PUMP FLOW DIVIDER “PF”
291
907878/DP0208
Hydraulics
DL Series Dynalift
Joystick Controller - Tri-Function
(Four-Button)
Refer to “Hydraulic Components”
section for a complete listing of
parts for the controller.
2
3
4
1
4
3
P
T
2
10
5
9
8
6
7
907878/DP0208
292
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Joystick Controller - Tri-Function
(Four-Button)
Ref.
No.
02
03
04
05
06
Part
No.
Description
L50211
L50051
L444002
L69906
L69906
Qty.
Req.
1/4-20X3/4” BOLT . . . . . . . . . . . . . . 4
1/4-20 FLANGE NUT. . . . . . . . . . . . 4
ADAP -6ORM -6ORM STR . . . . . . . 6
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
Ref.
No.
Part
No.
07
08
09
10
L69928
L69930
L69906
L69906
PILOT “4”
Description
HOSE,
HOSE,
HOSE,
HOSE,
-4 A6/A6
-4 A6/A6
-4 A6/A6
-4 A6/A6
Qty.
Req.
25” . . . . . . . . . . . . 1
46” . . . . . . . . . . . . 1
110” . . . . . . . . . . . 1
110” . . . . . . . . . . . 1
Main Valve
(Early Style Shown)
PILOT “1”
ONLY UNITS EQUIPPED WITH
AUXILIARY HYDRAULICS
WILL HAVE THIS 4TH SECTION.
FRONT
PILOT “2”
PILOT “3”
Hose Locator
Ref
No.
From Port
05
06
07
08
09
10
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
PRINTED IN U.S.A.
To Port
“3”
“2”
“T”
“P”
“1”
“4”
V40 PILOT “3”
V40 PILOT “2“
SAHR VALVE “P2”
V40 PILOT “1”
V40 PILOT “4”
293
907878/DP0208
Hydraulics
DL Series Dynalift
Joystick Controller - Dual-Function
(Two-Button)
Refer to “Hydraulic Components”
section for a complete listing of
parts for the controller.
2
3
4
1
4
3
P
T
2
10
5
9
8
6
7
907878/DP0208
294
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Joystick Controller - Dual-Function
(Two-Button)
Ref.
No.
02
03
04
05
06
Part
No.
Description
L50211
L50051
L444002
L69905
L69906
Qty.
Req.
1/4-20X3/4” BOLT . . . . . . . . . . . . . . 4
1/4-20 FLANGE NUT. . . . . . . . . . . . 4
ADAP -6ORM -6ORM STR . . . . . . . 6
HOSE, -4 A6/A6 130” . . . . . . . . . . . 1
HOSE, -4 A6/A6 110” . . . . . . . . . . . 1
Ref.
No.
Part
No.
Description
07
08
09
10
L69928
L69930
L69905
L69906
HOSE,
HOSE,
HOSE,
HOSE,
-4 A6/A6
-4 A6/A6
-4 A6/A6
-4 A6/A6
Qty.
Req.
25” . . . . . . . . . . . . 1
46” . . . . . . . . . . . . 1
130” . . . . . . . . . . . 1
110” . . . . . . . . . . . 1
STANDARD HYDRAULICS
Main Valve
(Early Style Shown)
AUXILIARY HYDRAULICS
Auxiliary PILOT
MANIFOLD
PILOT ”1”
A
T1
T2
B
4
B
4
2
A
T1
T2
FRONT
PILOT ”3”
2
STANDARD PILOT
MANIFOLD
Hose Locator
Ref
No.
From Port
05
06
07
08
09
10
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
To Port
---- STANDARD HYDRAULICS ---“3”
“2”
“T”
“P”
“1”
“4”
V40 PILOT “1“
SAHR VALVE “P2”
V40 PILOT “3”
---- AUXILIARY HYDRAULICS ---05
06
07
08
09
10
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
JOYSTICK
PRINTED IN U.S.A.
“3”
“2”
“T”
“P”
“1”
“4”
Auxiliary PILOT APPLY MANIFOLD “B”
SAHR VALVE “P2”
AUXILIARY PILOT APPLY MANIFOLD “A”
295
907878/DP0208
Hydraulics
DL Series Dynalift
Return Manifold and Filter Group
2
1
3
RETURN
MANIFOLD
19
7
4
5
18
Only on units equipped
with outriggers
6
FRONT
8
9
10
12
11
HYDRAULIC
TANK
13
17
16
10
15
14
907878/DP0208
296
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Return Manifold and Filter Group
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
L69933
L69927
L69928
L69920
L69907
L69922
L69928
L445003
L70378
L62954
L448002
L99970
13
L70497
Description
Qty.
Req.
Ref.
No.
HOSE, -6 A6/A8 60” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 81” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 25” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -4 A6/DS6 84” . . . . . . . . . . . 1
HOSE, -6 A6/A6 50” . . . . . . . . . . . . 1
HOSE, -4 A6/A6 25” . . . . . . . . . . . . 1
TANK DIFFUSER . . . . . . . . . . . . . . 1
ADAP 1/8NPTM 1/8NPTF 45 DEG . 1
RESTRICTION SWITCH . . . . . . . . . 1
HOSE, -16 A20/DL16 30” . . . . . . . . 1
14ac
Part
No.
L69309
L99459
L500352
L51587
101439
L70377
P471353
L70692
15
16
17
18b
19b
Description
Qty.
Req.
RETURN FILTER KIT . . . . . . . . . . . 1
HYD. FILTER CARTRIDGE . . . . . . 1
O RING . . . . . . . . . . . . . . . . . . . . . 1
TUBE, FILTER TO TANK. . . . . . . . . 1
HYDRAULIC TANK WELDMENT . . 1
ADAP -12ORM -10JICM 90 . . . . . . 1
HOSE, -12 A12/NS10 51”. . . . . . . . 1
a
Return filter includes Housing, L99459 filter
cartridge, L500352 o ring and L99970 switch.
b
Used only on units equipped with outriggers.
c
Kit consists of the housing, filter cartridge, o ring,
and item #12 restriction switch.
Hose Locator
Ref
No.
From Port
To Port
01
02
03
04
05
06
07
13
19*
STEER MOTOR “T” (IN CAB)
BRAKE VALVE “T” (IN CAB)
JOYSTICK “T” (IN CAB)
FLOW DIVIDER “T” (ON HYD. PUMP)
LEVEL VALVE “T”
SAHR “T”
LOWER COOLER (NEAREST RADIATOR)
HYDRAULIC TANK
HYDRAULIC RETURN FILTER
V20 VALVE “OUT”
* Used only on units equipped with outriggers.
PRINTED IN U.S.A.
297
907878/DP0208
Hydraulics
DL Series Dynalift
Frame Level Cylinder Group
FRONT
6
5
4
2
1
7
3
8
9
A
B
7
3
8
10
11
12
13
23
8
22
14
15
24
16
25
17
21
20
27
FR
26
ON
TA
XL
E
Current Style
18
19
907878/DP0208
298
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Frame Level Cylinder Group
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16a
L69725
L64367
L445005
L63015
L70385
L69724
L50230
L50143
L10465
L69921
L69921
L63716
L63715
L50561
L520005
L69275
Description
L70128
17
18
19
20
21
L63016
L69382
100255
L50084
L50684
L50275
Qty.
Req.
Ref.
No.
Part
No.
Description
PIN LOCK CAP 2” . . . . . . . . . . . . . . 1
BUSHING (Base end) . . . . . . . . . . . 1
FRAME LEVEL CYL. 4X7.5 . . . . . . 1
LEVEL CYLINDER PIN . . . . . . . . . . 1
PIVOT PIN LOCK CAP . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 4
5/16” LOCK WASHER . . . . . . . . . . . 6
ZERK, 1/4-28 STR. . . . . . . . . . . . . . 1
HOSE -4 A6/A6 126” . . . . . . . . . . . . 1
HOSE -4 A6/A6 126” . . . . . . . . . . . . 1
TWIN HOSE CUSHION 11/16” . . . . 2
TWIN CUSH. TOP PLATE. . . . . . . . 1
5/16-18X1-3/4” BOLT . . . . . . . . . . . 2
LEVEL MOUNT WELDMENT . . . . . 1
(Model DL6)
(Model DL8, DL10 and DL12)
BUSHING (ROD END) . . . . . . . . . . 1
LEVEL MOUNT PLATE . . . . . . . . . . 1
Note a
Note b
3/4-10 NUT GR8 . . . . . . . . . . . . . . . 4
3/4-10X11” GR8 BOLT . . . . . . . . . . 4
3/8-16X3” BOLT. . . . . . . . . . . . . . . . 1
22a
23
24b
25b
26b
27b
L63275
L10057
L68882
100252
L68881
L50403
a
b
Qty.
Req.
LEVEL CYL. PIN (ROD END) . . . . . 1
ZERK, 1/4-28 90 DEG. . . . . . . . . . . 1
LEVEL CYL MOUNT WELDMENT . 1
LOCK, PIVOT PIN . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
Hose Locator
Ref
No.
From Port
To Port
10
11
LEVEL CYLINDER “A”
LEVEL CYLINDER “B”
LEVEL VALVE “A1”
LEVEL VALVE “B1”
PRINTED IN U.S.A.
299
907878/DP0208
Hydraulics
DL Series Dynalift
Frame Stabilizer Cylinder Group
16
1
5
4
3
2
M
2
L
3
4
5
6
LEVEL
VALVE
“B2”
7
LEVEL
VALVE
“A2”
FRONT
15
8
14
17
18
10
9
13
RE
AR
20
AX
LE
19
Current Style
12
11
907878/DP0208
300
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Frame Stabilizer Cylinder Group
Ref.
No.
Part
No.
01c
L70358
02
03
04
05
06
07
08
09d
L445003
L69774
L69776
L50230
L70084
L70084
L520005
L69275
Description
13
14
15
16c
17e
18e
19e
20e
Ref.
No.
FRAME STABILIZER CYLINDER . . 1
(Cylinder only - does not include #16)
BUSHING . . . . . . . . . . . . . . . . . . . . 2
TRUNNION PIVOT PIN. . . . . . . . . . 2
5/16”-18X3/4” BOLT . . . . . . . . . . . . 4
HOSE, -4 A6/DS6 65” . . . . . . . . . . . 1
HOSE, -4 A6/DS6 65” . . . . . . . . . . . 1
(Model DL6)
3/4-10X11” GR8 BOLT . . . . . . . . . . 4
3/4-10 NUT GR8 . . . . . . . . . . . . . . . 4
LEVEL MOUNT PLATE . . . . . . . . . . 1
Note d
Note e
3/8-16X3” BOLT. . . . . . . . . . . . . . . . 1
BUSHING (Rod End). . . . . . . . . . . . 1
FRAME LEVEL CYL PIN . . . . . . . . . 1
STABILIZER CYL. MANIFOLD . . . . 1
Note a (4” leads)
Note b (72” leads)
LEVEL CYL MOUNT WELDMENT . 1
LOCK, PIVOT PIN . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 1
L70128
10
11
12
Qty.
Req.
L50684
L50084
L69382
100255
L50275
L69138
L63275
L66885
L71166
L68882
100252
L68881
L50403
Part
No.
Description
Qty.
Req.
a
b
DL12H SN ALL
c
Refer to Stabilizer Manifold break down page for
manifold, valves, hardware and tubes).
d
e
Hose Locator
Ref
No.
From Port
To Port
06
07
STABILIZER CYLINDER MANIFOLD “L”
STABILIZER CYLINDER MANIFOLD “M”
LEVEL VALVE “A2”
LEVEL VALVE “B2”
PRINTED IN U.S.A.
301
907878/DP0208
Hydraulics
DL Series Dynalift
Lift Cylinder Group
1
A
B
LIFT CYLINDER
HYDRAULIC
MANIFOLD
RIGHT
6
5
7
2
8
3
9
10
4
MAIN VALVE
A
11
A
B
4
12
13
DC
3
2
B
14
14
15
23 22
15
21
SLAVE CYLINDER
TUBES
17
16
LEFT
D C
20
19
18
10
FRONT
907878/DP0208
302
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Lift Cylinder Group
Ref.
No.
01
Part
No.
Description
L69125
LIFT CYLINDER (RH) . . . . . . . . . . . 1
(Model DL6)
LIFT CYLINDER (RH) . . . . . . . . . . . 1
HOSE -8 A10/DS10 24”. . . . . . . . . . 2
HOSE -8 A10/DS10 23”. . . . . . . . . . 2
HOSE -12 A12/DS10 36”. . . . . . . . . 2
BUSHING 2X2.25X3.5” . . . . . . . . . . 2
LIFT PIN (ROD END) . . . . . . . . . . . 2
LIFT CYLINDER (LH) . . . . . . . . . . . 1
(Model DL6)
LIFT CYLINDER (LH) . . . . . . . . . . . 1
L69135
02
03
04
05
06
07
08
09
Qty.
Req.
L444010
L70806
L70460
L69913
L445090
L69142
L69600
L69564
L69565
Ref.
No.
Part
No.
10
11
12
13
14
15
16
17
18
19
20
21
22
23
L10465
L60986
L69557
L68039
L63715
L50143
L50561
L520005
L69599
L50275
L69138
L69558
L520004
L50877
Description
Qty.
Req.
1/4-28 GREASE ZERK STR . . . . . . 4
PLUG -4ORM . . . . . . . . . . . . . . . . . 2
LIFT/SLAVE TUBE ASSEMBLY . . . 1
DOUBLE TUBE CUSHION . . . . . . . 4
TWIN CUSHION TOP PLATE . . . . . 2
5/16” LOCK WASHER . . . . . . . . . . . 2
5/16-18X1-3/4” BOLT . . . . . . . . . . . 2
LIFT PIN (BASE END). . . . . . . . . . . 2
3/8-16X3” BOLT. . . . . . . . . . . . . . . . 4
BUSHING . . . . . . . . . . . . . . . . . . . . 2
5/16-18X2-1/4” STUD . . . . . . . . . . . 2
Hose Locator
Ref
No.
From Port
To Port
03
04
05
LIFT CYLINDER/MANIFOLD “A”
LIFT CYLINDER/MANIFOLD “B”
LIFT/SLAVE TUBE ASSEMBLY “A & B”
LIFT/SLAVE TUBE ASSEMBLY “A” (as shown)
LIFT/SLAVE TUBE ASSEMBLY “B” (as shown)
V40 VALVE “A & B” (as shown)
PRINTED IN U.S.A.
303
907878/DP0208
Hydraulics
DL Series Dynalift
Slave Cylinder Group
1
6
8
7
RIGHT
5
9
26
5
D
4
2
27
10
D
4
3
28
29
C
30
C
25
16
LEFT
11
12
13
16
14
25
15
BA
C
LIFT CYLINDER
TUBES
D
BA
C
18
19
D
17
12
24
23
22
21 20
19
18
9
10
Early version
FRONT
907878/DP0208
304
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Slave Cylinder Group
Ref.
No.
01
Part
No.
Description
L69149
SLAVE CYLINDER (RH) . . . . . . . . . 1
(High boom models)
SLAVE CYLINDER (RH) . . . . . . . . . 1
(Low boom models)
ADAP -12JICM BLKHD R TEE . . . . 2
HOSE -8 A8/A10 57” . . . . . . . . . . . . 2
SLAVE CYL. PIN (ROD END) . . . . . 2
BUSHING 660 1.5IDX3.0 . . . . . . . . 2
1/4-28 GREASE ZERK STR . . . . . . 2
PIN LOCK BAR . . . . . . . . . . . . . . . . 2
5/16-18X3/4” BOLT . . . . . . . . . . . . . 4
BUSHING . . . . . . . . . . . . . . . . . . . . 2
SLAVE CYLINDER PIN . . . . . . . . . . 2
Note a and note e
Note b
WASHER, .41 IDX2.0OD . . . . . . . . 2
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 2
1/4-28 GREASE ZERK 90 DEG . . . 2
HOSE -8 A8/A10 38” . . . . . . . . . . . . 2
DOUBLE TUBE CUSHION . . . . . . . 4
5/16-18X2-1/4” STUD . . . . . . . . . . . 2
5/16-18X1-3/4” BOLT . . . . . . . . . . . 2
5/16” LOCK WASHER . . . . . . . . . . . 2
HOSE -8 A12/DS10 50”. . . . . . . . . . 2
3/8” ROD END. . . . . . . . . . . . . . . . . 1
3/8”-16X1-1/4” BOLT . . . . . . . . . . . . 1
PROXIMITY SENSOR ROD . . . . . . 1
3/8”-24 NUT . . . . . . . . . . . . . . . . . . 1
SLAVE CYLINDER (LH) . . . . . . . . . 1
(High boom models)
SLAVE CYLINDER (LH) . . . . . . . . . 1
(Low boom models)
L69139
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
Qty.
Req.
P471299
L446020
L69910
L445002
L70176
L63018
L10465
L70177
L50230
L68003
L70576
L71222
L50170
L50251
L10057
L69911
L69558
L68039
L63715
L50877
L520004
L69557
L50561
L50143
L69908
L70183
L50403
L70182
L50066
L70251
L70240
Ref.
No.
Part
No.
30
L70086
L71165
Description
Qty.
Req.
PROXIMITY SWITCH . . . . . . . . . . . 1
Note c
Note d
---- SERIAL NUMBERS---DL6H SN 20328 and before
a
b
DL12H SN ALL
c
d
DL12H SN ALL
e
Use along with item #9 and item #10 for each pin.
Hose Locator
Ref
No.
From Port
To Port
04
16
25
25
SLAVE CYLINDER “D”
SLAVE CYLINDER “C”
LIFT/SLAVE TUBE ASSEMBLY “D”
LIFT/SLAVE TUBE ASSEMBLY “C”
LIFT/SLAVE TUBE ASSEMBLY “D” (as shown)
LIFT/SLAVE TUBE ASSEMBLY “C” (as shown)
(RIGHT) BULKHEAD TEE FITTING ABOVE V40
(LEFT) BULKHEAD TEE FITTING ABOVE V40
PRINTED IN U.S.A.
305
907878/DP0208
Hydraulics
DL Series Dynalift
Tilt Cylinder Group - Low Boom
(Three-Section Boom)
2
1
4
5
6
3
8
7
9
10
9
11
8
4
22
21
19
1
23
18
12
17
16
20
24
12
21
25
15
26
14
27
MAIN VALVE
30 24
19
31
28
29
FRONT
907878/DP0208
306
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
01
02
Part
No.
L69832
L69822
L70276
L70277
03
04
05
06
07
08
09
10
L70095
L70632
L520004
L50877
L67446
L67341
L69833
L50235
L69983
L71027
11
12
14
15
16
17
18
19
20
21
22d
23
L69984
L71028
P471299
L444001
L520005
L50801
L69976
L69127
L10465
L63720
L63719
L71104
L50884
PRINTED IN U.S.A.
Description
Qty.
Req.
TUBE CLAMP PAIR, 5/8” DIA. . . . . 5
TUBE, TILT/AUX BOTTOM . . . . . . . 2
Note a
Note b
Note c
HOSE. . . . . . . . . . . . . . . . . . . . . . . . 2
Note e (HOSE -12 H12/DS12 66”)
Note f (HOSE -12 H10/Z12 53”)
5/16-18X2-1/4” STUD . . . . . . . . . . . 4
TUBE CUSHION TOP PLATE . . . . 2
TUBE CUSHION, SINGLE 5/8” . . . 4
TUBE CLAMP TOP PLATE . . . . . . . 5
5/16-18X1-1/4” BOLT . . . . . . . . . . . 5
TILT CYLINDER TUBE (RH) . . . . . . 1
Note e
Note f
TILT CYLINDER TUBE (LH) . . . . . . 1
Note e
Note f
3/8-16X4” BOLT. . . . . . . . . . . . . . . . 1
PIN, TILT CYL BASE END . . . . . . . 1
BUSHING (BASE END). . . . . . . . . . 1
1/4”-28 GREASE ZERK STR. . . . . . 2
TUBE CUSHION, DBL . . . . . . . . . . 4
HOSE CUSHION TOP PLATE . . . . 1
5/16-18X4-1/2” STUD . . . . . . . . . . . 2
5/16-18X2-1/4” BOLT . . . . . . . . . . . 2
Ref.
No.
Part
No.
24
25
L50143
Description
Qty.
Req.
5/16” LOCK WASHER . . . . . . . . . . . 4
HOSE -8 H10/P10 . . . . . . . . . . . . . . 2
Note a
Note b
Note c
HOSE SLEEVE . . . . . . . . . . . . . . . 1
TILT CYLINDER, LOW BOOM . . . . 1
PLUG, AIRWAY -4ORM . . . . . . . . . . 1
PIN, TILT CYL ROD END . . . . . . . . 1
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 2
26
27
28
29
30
31
L70100
L70098
L70094
L500784
L69751
L60986
L70308
L99891
L69724
L50230
a
b
c
Use with 40’ Low Boom
d
Units equipped with Auxiliary Hydraulics use
part number L71656 5/16-18x6” STUD
e
f
307
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
22
1
21
49
48
47
18
44
17 16
46
45
43
42
40 41
22 37
38
50
9
8
10
7
13
6
12
39
5
4
3
2
11
14
16
35 36
34
15
17
18
19
33
20
32
21
22
23
24
Refer to previous page for a
listing of components and
hoses attached to main valve.
25
31
30
26
29
28
907878/DP0208
27
308
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10a
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
L70632
L10057
L71016
L50157
L71389
L71347
L71014
L71213
L443011
L71391
L71037
L71036
L69822
L71042
L50486
L69832
L69833
L50235
L63717
L63715
L50877
L520004
L63720
L63719
L50884
L71047
L10465
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE ASY. -12X53 . . . . . . . . . . . . . 2
GREASE ZERK 90 1/4-28. . . . . . . . 2
HOSE RETAINER BOLT . . . . . . . . . 2
PLAIN WASHER .75 . . . . . . . . . . . . 2
HOSE RETAINER SPACER . . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
SHEAVE PIN WASHER. . . . . . . . . . 2
REAR SHEAVE PIN . . . . . . . . . . . . 1
ADAP -10JICM BLKHD 90 . . . . . . . 2
HOSE ASY. -8X254 (Twin Line) . . . 1
INNER TUBE . . . . . . . . . . . . . . . . . . 1
INNER TUBE . . . . . . . . . . . . . . . . . . 1
TILT TUBE . . . . . . . . . . . . . . . . . . . . 2
VINYL CLAMP . . . . . . . . . . . . . . . 10
CAPSCREW 1/4-20X5/8 . . . . . . . . . 5
DBL. TUBE CLAMP .63. . . . . . . . . . 4
TWIN TUBE TOP PLATE . . . . . . . . 4
CAPSCREW 5/16-18X1-1/4 . . . . . . 1
TWIN TUBE CUSHION .50 . . . . . . . 1
TWIN NARROW TOP PLATE . . . . . 1
STUD 5/16-18X2-1/4 . . . . . . . . . . . 6
NYLON INSERT NUT 5/16-18 . . . . 7
TWIN CUSHION .88 . . . . . . . . . . . . 1
TWIN WIDE TOP PLATE. . . . . . . . . 1
CAPSCREW 5/16-18X2-1/4 . . . . . . 2
HOSE ASY. -8X54 . . . . . . . . . . . . . . 2
GREASE ZERK STR. 1/4-28 . . . . . 1
Ref.
No.
Part
No.
28
29
30
31
32
33
34
35
36
37
38
39
40
L50230
L50143
L69724
L70308
L520005
L60986
L69751
L69976
L50801
L71104
L63719
L71421
L71055
L99134
L50056
L71747
L71705
L71748
L51035
L71028
L71027
L67341
L67446
L71010
41
42
43
44
45
46
47
48
49
50
a
309
Description
Qty.
Req.
CAPSCREW 5/16-18X3/4 . . . . . . . . 2
LOCKWASHER 5/16 . . . . . . . . . . . . 2
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
ROD END PIN . . . . . . . . . . . . . . . . . 1
NYLON INSERT NUT 3/8-16 . . . . . 1
MALE PLUG (-4OR) . . . . . . . . . . . . 1
TILT CYL. 5-1/2D X 16-1/4 . . . . . . . 1
BASE END PIN . . . . . . . . . . . . . . . . 1
CAPSCREW 3/8-16X4 . . . . . . . . . . 1
STUD 5/16-18X4-1/2 . . . . . . . . . . . . 2
TWIN WIDE TOP CLAMP . . . . . . . . 1
TWIN HOSE CUSHION. . . . . . . . . . 2
HOSE ASY. -8X268 . . . . . . . . . . . . . 2
HOSE SLEEVE . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
CLAMP BOTTOM . . . . . . . . . . . . . . 1
CLAMP TOP . . . . . . . . . . . . . . . . . . 1
TOP PLATE . . . . . . . . . . . . . . . . . . . 1
5/16”-18X2” BOLT . . . . . . . . . . . . . . 1
LT. REAR TUBE . . . . . . . . . . . . . . . 1
RT. REAR TUBE . . . . . . . . . . . . . . . 1
SGL. TUBE CUSHION .63 . . . . . . . 4
SGL. CUSHION TOP PLATE . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
Units equipped with two individual hydraulic
hoses requires hose replacement kit L500438.
907878/DP0208
Hydraulics
DL Series Dynalift
Tilt Cylinder Group - High Boom
2
1
4
5
3
6
7
2
10
8
9
11
15
9
8
16
16
8
15
9
17
31
18
12
30
19
29
20
14
28
27
26 25
21
22
17
907878/DP0208
23
24
310
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
14
15
16
17
L70092
L70090
L69944
L500784
L79167
L50056
L69453
L69452
L67341
L67446
L50877
L520004
L443011
L69947
P471299
L444001
L68039
L63715
L40165
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE -8 H10/H10 . . . . . . . . . . . . . . 2
Note a
Note b
Note c
HOSE SLEEVE . . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 2
TILT CYLINDER TUBE . . . . . . . . . . 1
TUBE CUSHION, SINGLE 5/8” . . 12
5/16-18X2-1/4” STUD . . . . . . . . . . 16
5/16-18 NYLON INSERT NUT . . . 16
ADAP -10JICM BLKHD 90 DEG . . . 2
HOSE -12 A10/DS12 42”. . . . . . . . . 2
TUBE CUSHION DBL 5/8” . . . . . . . 4
HOSE CUSHION TOP PLATE . . . . 2
1/4”-28 GREASE ZERK STR. . . . . . 2
Ref.
No.
Part
No.
18
19
20
21
22
23
24
25
26
27
28
29
30
31
L69601
L50277
L520005
L69144
L69727
L69724
L50230
L60986
L444010
L51599
P471356
L70088
L69449
L69450
a
b
c
Use with 40’ High Boom
311
Description
Qty.
Req.
PIN, TILT CYL BASE END . . . . . . . 1
3/8-16X3-1/2” BOLT . . . . . . . . . . . . 1
3/8” NYLON INSERT NUT . . . . . . . 1
TILT CYLINDER - 5.5X20.0. . . . . . . 1
PIN, TILT CYL ROD END . . . . . . . . 1
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
5/16-18X3/4” BOLT . . . . . . . . . . . . . 2
PLUG, AIRWAY -4ORM . . . . . . . . . . 1
HOSE -8 A10/H10 20” . . . . . . . . . . . 2
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
51
50
49
48
50
52
41
40
48
47
46
47
46
45
39
43
44
42
38
37
36
2
1
35
18
31
34
3
32
4
33
8
09
5
7
6
10
28
12
13
12
29
11
14
30
15 16
18
18
14 27
17
26
18
19
20
25
24
21
22
15
907878/DP0208
23
312
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
Part
No.
L443011
L71033
L71034
L69832
L69833
L50235
L50486
L71042
L69832
L69833
L50235
L63717
L63715
L50877
L10465
L69601
L50275
L520004
L69144
L60986
L69727
L69724
L50230
L51599
P471356
L444010
L71043
L63715
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
ADAP -10JICM BLKHD 90 . . . . . . . 2
OUTER REAR TUBE . . . . . . . . . . . 1
OUTER REAR TUBE . . . . . . . . . . . 1
DOUBLE TUBE CLAMP .62 . . . . . . 1
CLAMP TOP PLATE . . . . . . . . . . . . 1
CAPSCREW 5/16-18X1-1/4 . . . . . . 1
CAPSCREW 1/4-20X5/8 . . . . . . . . . 5
VINYL CLAMP . . . . . . . . . . . . . . . . 10
DOUBLE TUBE CLAMP .62 . . . . . . 4
CLAMP TOP PLATE . . . . . . . . . . . . 4
CAPSCREW 5/16-18X1-1/4 . . . . . . 4
STUD 5/15-18X2-1/4 . . . . . . . . . . . 2
GREASE ZERK STR. 1/4-28 . . . . . 2
BASE END PIVOT PIN . . . . . . . . . . 1
CAPSCREW 5/16-18X3 . . . . . . . . . 1
NYLON INSERT NUT 5/16 . . . . . . . 2
TILT CYLINDER . . . . . . . . . . . . . . . 1
PLUG, -4ORM . . . . . . . . . . . . . . . . . 1
ROD END PIVOT PIN . . . . . . . . . . . 1
PIVOT PIN CAP . . . . . . . . . . . . . . . 1
CAPSCREW 5/16-18X3/4 . . . . . . . . 2
MALE 90 EL. (-10OR/-10JIC) . . . . . 1
SWVL. 90 EL. (-10JICF/-10JICM) . . 1
ADAP -10ROM -10JICM STR . . . . . 1
HOSE ASY. -8X20 . . . . . . . . . . . . . . 2
29
30
31
32
33
34a
35
L71038
L71039
L71104
L63719
L71421
L71391
L71046
L99134
L71035
L50056
L71747
L71705
L71748
L51035
L71037
L71036
L40347
L10057
L71016
L50157
L71389
L71010
L71014
L71213
L71347
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
a
313
Description
Qty.
Req.
INNER NOSE TUBE . . . . . . . . . . . . 1
INNER NOSE TUBE . . . . . . . . . . . . 1
STUD 5/16-18X4.5 . . . . . . . . . . . . . 2
TWIN HOSE CUSHION .88 . . . . . . 2
HOSE ASY. -8X254 . . . . . . . . . . . . . 1
HOSE ASY. -8X290” . . . . . . . . . . . . 2
HOSE SLEEVE . . . . . . . . . . . . . . . 1
OUTER FRONT TUBE . . . . . . . . . . 2
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
CLAMP BOTTOM . . . . . . . . . . . . . . 1
CLAMP TOP . . . . . . . . . . . . . . . . . . 1
TOP PLATE . . . . . . . . . . . . . . . . . . . 1
5/16”-18X2” BOLT . . . . . . . . . . . . . . 1
INNER TUBE . . . . . . . . . . . . . . . . . . 1
INNER TUBE . . . . . . . . . . . . . . . . . . 1
BULKHD. 90 (-8JICM) . . . . . . . . . . . 2
GREASE ZERK 90 1/4-28. . . . . . . . 1
RETAINER BOLT. . . . . . . . . . . . . . . 1
PLAIN WASHER 3/4 . . . . . . . . . . . . 2
RETAINER SPACER . . . . . . . . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
PIN WASHER . . . . . . . . . . . . . . . . . 2
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
Units equipped with two individual hydraulic hoses
requires hose replacement kit L500438. Kit
includes twinline hose assemblies.
907878/DP0208
Hydraulics
DL Series Dynalift
Extend Cylinder Group - Low Boom
9
7
10
8
27
26
4
28
6
3
5
29
11
2
1
12
25
13
24
9
14
14
15
22
16
23
21
18
17
18
20
20
MAIN VALVE
907878/DP0208
314
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01
02
Note a
L69486
03
04
05
06
07
08
09
10
11
12
13
L48805
L50313
L50156
L69994
L50608
L50519
L50956
L69480
L400207
L70420
L69485
14
L70096
L70633
15
16
17
18
20
21
22
L69980
L70705
L69982
L445001
L446034
L444001
L69979
L70706
L69981
PRINTED IN U.S.A.
Description
Qty.
Req.
EXTEND CYLINDER. . . . . . . . . . . . 1
TRUNNION MOUNT (RH). . . . . . . . 1
(Includes item 3)
BUSHING 2.O” ID X 1.0” LENGTH . 2
5/8-11x1-1/2” BOLT . . . . . . . . . . . . 10
5/8” LOCK WASHER . . . . . . . . . . . 10
3/16X4” COTTER PIN . . . . . . . . . . . 2
3/4-10X2-1/2” BOLT . . . . . . . . . . . . 8
EXT CYL MOUNT WELDMNT . . . . 1
THRUST WASHER . . . . . . . . . . . . . 2
TRUNNION SHIM . . . . . . . . . . . . . . 1
TRUNNION MOUNT (LH) . . . . . . . . 1
(Includes item 3)
HOSE. . . . . . . . . . . . . . . . . . . . . . . . 2
Note b (HOSE -12 H10/DS12 66”)
Note c (HOSE -12 H12/Z12 53”)
EXTEND CYLINDER TUBE (LH) . . 1
Note b
Note c
EXTEND CYLINDER TUBE (RH) . . 1
Note b
Note c
EXTEND CYLINDER TUBE (RH) . . 1
Ref.
No.
Part
No.
23
24
25
26
27
28
29
L61709
L50147
L50251
L50877
L520004
L67446
L70270
a
b
c
315
Description
Qty.
Req.
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 2
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 2
5/16”-18X2-1/4” STUD. . . . . . . . . . . 4
CUSHION BLOCK TOP . . . . . . . . . 2
CLAMP, SINGLE .75 TUBE. . . . . . . 4
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
10
9
8
7
2
11
12
3
13
14
14 13 12
6
10
15
5
15
1
8
2
16
15
7
4
3
907878/DP0208
316
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
L71024
L50275
L520005
L64559
L10465
L70972
L445001
L71050
PRINTED IN U.S.A.
Description
Qty.
Req.
EXTEND CYLINDER. . . . . . . . . . . . 1
3/8”-16X3” BOLT . . . . . . . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 2
ROD PIN, 1.75 DX7.25 . . . . . . . . . . 1
GREASE ZERK STR. 1/4-18 . . . . . 2
RETAINER. . . . . . . . . . . . . . . . . . . . 1
ADAP -12ORM -12JIC 90 . . . . . . . . 2
HOSE ASY. -12x20-. . . . . . . . . . . . . 2
Ref.
No.
Part
No.
09
10
11
12
13
14
15
16
L71029
L70633
L70964
L520004
L50877
L67440
L70270
L71030
317
Description
Qty.
Req.
REAR TUBE (RH) . . . . . . . . . . . . . . 1
HOSE ASY. -12X53 . . . . . . . . . . . . . 2
BASE END PIN, 1.75 DX5.25 . . . . . 1
5/16-18X2-1/4” STUD . . . . . . . . . . . 8
SINGLE CUSH. TOP PLATE. . . . . . 4
SINGLE TUBE CUSHION .75 . . . . . 8
REAR TUBE (LH) . . . . . . . . . . . . . . 1
907878/DP0208
Hydraulics
DL Series Dynalift
Extend Cylinder Group - High Boom
8
2
1
4
3
23
9
5
22
12
6
6
21
7
4
20
10
8
16
19
17
3
15
11
12
18
12
12
14
MAIN VALVE
907878/DP0208
318
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
14
Part
No.
L50156
L50313
L445001
L50608
L69994
L400207
L69480
L50956
L50519
L70420
L69448
L446034
L444001
PRINTED IN U.S.A.
Description
Qty.
Req.
5/8” LOCK WASHER . . . . . . . . . . . 10
5/8-11x1-1/2” BOLT . . . . . . . . . . . . 10
3/16X4” COTTER PIN . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 2
EXT CYL MOUNT WELDMNT . . . . 1
3/4-10X2-1/2” BOLT . . . . . . . . . . . . 8
TRUNNION SHIM . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
15
16
L69946
L69485
17
18
19
20
21
22
Note a
L61709
L50147
L50251
L69447
L69486
23
L48805
a
319
Description
Qty.
Req.
HOSE -12 A12/DS12 42”. . . . . . . . . 2
TRUNNION MOUNT (LH) . . . . . . . . 1
(Includes item 23)
EXTEND CYLINDER. . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 2
3/8-16X3/4” BOLT . . . . . . . . . . . . . . 2
EXTEND CLYINDER TUBE (RH) . . 1
TRUNNION MOUNT (RH). . . . . . . . 1
(Includes item 23)
BUSHING 2.O” ID X 1.0” LENGTH . 2
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
11
11
10
9
10
3
1
12
9
2
8
4
3
7
6
5
907878/DP0208
4
320
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
01
02
04
03
05
06
Part
No.
L71023
L64559
L50275
L520005
L50282
L50152
PRINTED IN U.S.A.
Description
Qty.
Req.
EXTEND CYLINDER. . . . . . . . . . . . 1
ROD PIN, 1.75 DX7.25 . . . . . . . . . . 1
3/8”-16X3” BOLT . . . . . . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 2
1/2-13”X1” BOLT . . . . . . . . . . . . . . 1
1/2” LOCKWASHER . . . . . . . . . . . . 1
Ref.
No.
Part
No.
07
08
09
10
11
12
P272700
L10465
L445001
L71051
L446034
L70964
321
Description
Qty.
Req.
ISOLATOR . . . . . . . . . . . . . . . . . . . . 1
GREASE ZERK STR. 1/4-18 . . . . . 2
MALE 90 ELBOW (-12OR/-12JIC) . 2
HOSE ASY. -12X36 . . . . . . . . . . . . . 2
BULKHD. 90 (-12JICM) . . . . . . . . . . 2
BASE END PIN, 1.75 DX5.25 . . . . . 1
907878/DP0208
Hydraulics
DL Series Dynalift
Auxiliary Hydraulics - Low Boom
2
1
4
8
9
4
8
3
6
7
10
9
5
11
21
1
5
12
22
20
12
19
14
18
17
MAIN VALVE
Refer to Pilot Manifold
pages for more information
FRONT
907878/DP0208
15
322
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
01
02
Part
No.
L69832
L69822
L70276
L70277
03
04
05
06
07
08
09
10
L70095
L70632
L520004
L50877
L67446
L67341
L69833
L50235
L69985
L70703
11
12
14
15
17f
18f
19
20
21
22
L69986
L70704
L446034
L444001
L444002
NSS
NSS
L444011
L70113
L70111
L70102
L500784
L63720
L63719
PRINTED IN U.S.A.
Description
Qty.
Req.
TUBE CLAMP PAIR, 5/8” DIA. . . . . 5
TUBE, TILT/AUX BOTTOM . . . . . . . 2
Note a
Note b
Note c
HOSE. . . . . . . . . . . . . . . . . . . . . . . . 2
Note d (HOSE -12 H12/DS12 66”)
Note e (HOSE -12 H10/Z12 53”)
5/16-18X2-1/4” STUD . . . . . . . . . . . 6
TUBE CUSHION, SINGLE 5/8” . . . 4
TUBE CLAMP TOP PLATE . . . . . . . 5
5/16-18X1-1/4” BOLT . . . . . . . . . . . 5
TUBE AUX. HYD.(Right) . . . . . . . . . 1
Note d
Note e
TUBE AUX. HYD (Left) . . . . . . . . . . 1
Note d
Note e
ADAP -6ORM -6JICM STR . . . . . . . 2
COUPLER, FEMALE/FLAT . . . . . . . 1
COUPLER, MALE/FLAT . . . . . . . . . 1
ADAP -8ORM -10JICM STR . . . . . . 2
HOSE -8 H10/A10 . . . . . . . . . . . . . . 2
Note a
Note b
Note c
HOSE SLEEVE . . . . . . . . . . . . . . . . 1
TUBE CUSHION, DBL 3/4” DIA . . . 4
TOP PLATE -TWIN WIDE . . . . . . . . 1
Ref.
No.
a
b
c
d
Part
No.
Description
Qty.
Req.
e
f
Order P/N L65273 coupler set.
NOTE: Refer to the pilot manifolds page for a detailed
view of the hoses.
323
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
30
29
1
42
40
39
18
17
16
9
38
33
41
43
37
36
35
34
10
2
13
14
3
4
15
5
6
16
30 32
17
24
12
7
8
11
18
30
31
29 28
27
26
25
24
19
23
22
20
21
907878/DP0208
324
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10a
11
12
13
14
15
16
17
18
19
20
21b
22b
23
24
L70632
L10057
L71016
L50157
L71389
L71347
L71014
L71213
L443011
L71390
L71041
L71040
L69822
L71042
L50486
L69832
L69833
L50235
L71048
L444011
NSS
NSS
L63720
L63719
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE ASY. -12X53 . . . . . . . . . . . . . 2
GREASE ZERK 90 1/4-28. . . . . . . . 2
PLAIN WASHER .75 . . . . . . . . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
REAR SHEAVE PIN . . . . . . . . . . . . 1
ADAP -10JICM BLKHD 90 . . . . . . . 2
HOSE ASY. -8X248” . . . . . . . . . . . . 1
AUX. INNER BOTTOM TUBE . . . . . 1
AUX. INNER TOP TUBE . . . . . . . . . 1
FORWARD BOOM TUBE . . . . . . . . 2
VINYL CLAMP . . . . . . . . . . . . . . . 10
CAPSCREW 1/4-20X5/8 . . . . . . . . . 5
DBL. TUBE CLAMP .63. . . . . . . . . . 4
TWIN TUBE TOP PLATE . . . . . . . . 4
CAPSCREW 5/16-18X1-1/4 . . . . . . 1
HOSE -8X15”. . . . . . . . . . . . . . . . . . 2
ADAP -8ORM -10JICM STR . . . . . . 2
MALE COUPLER . . . . . . . . . . . . . . 1
FEMALE COUPLER . . . . . . . . . . . . 1
TWIN CUSHION .88. . . . . . . . . . . AR
Ref.
No.
Part
No.
25
26
27
28
29
30
31
32
33
L50884
L50143
L63717
L63714
L50877
L520004
L71421
L71104
L71055
L99134
L50056
L71747
L71705
L71748
L51035
L70704
L70703
L67341
L67446
L71010
34
35
36
37
38
39
40
41
42
43
Description
Qty.
Req.
CAPSCREW 5/16-18X2-1/4 . . . . . . 2
LOCKWASHER 5/16 . . . . . . . . . . . . 2
STUD 5/16-18X2-1/4 . . . . . . . . . . . 6
NYLON INSERT NUT 5/16-18 . . . . 7
STUD 5/16-18X4-1/2 . . . . . . . . . . . . 2
HOSE -8X268”. . . . . . . . . . . . . . . . . 2
HOSE SLEEVE . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
CLAMP BOTTOM . . . . . . . . . . . . . . 1
CLAMP TOP . . . . . . . . . . . . . . . . . . 1
TOP PLATE . . . . . . . . . . . . . . . . . . . 1
5/16”-18X2” BOLT . . . . . . . . . . . . . . 1
REAR RIGHT TUBE . . . . . . . . . . . . 1
REAR LEFT TUBE . . . . . . . . . . . . . 1
SGL. TUBE CUSHION .63 . . . . . . . 4
SGL. CUSHION TOP PLATE . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
a
hoses requires hose replacement kit L500438. Kit
b
Order PN L65273 coupler set.
325
907878/DP0208
Hydraulics
DL Series Dynalift
Auxiliary Hydraulics - High Boom
2
4
3
1
5
6
7
9
8
10
19
11
8
7
20
13
17
18
16
MAIN VALVE
14
Refer to Pilot Manifold
pages for more information
FRONT
907878/DP0208
326
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
L70107
L70105
L69945
L500784
L79167
L50056
L69451
L67341
L67446
L50877
L520004
L443011
L69947
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
HOSE -8 H10/A10 . . . . . . . . . . . . . . 2
Note a
Note b
Note c
HOSE SLEEVE . . . . . . . . . . . . . . . . 1
5/16-18 FLARE NUT . . . . . . . . . . . . 2
Auxiliary TUBE (BOTTOM) . . . . . . . 2
TUBE CUSHION, SINGLE 5/8” . . 12
5/16-18X2-1/4” STUD . . . . . . . . . . 16
5/16-18 NYLON INSERT NUT . . . 16
HOSE -12 A10/DS12 42”. . . . . . . . . 2
11
13
14
16d
17d
18
19
20
L446034
L444001
L444002
NSS
NSS
L444011
L63720
L63719
a
b
c
d
327
Description
Qty.
Req.
ADAP -12JICM BLKHD 90 . . . . . . . 2
ADAP -6ORM -6JICM . . . . . . . . . . . 2
COUPLER, FEMALE/FLAT . . . . . . . 1
COUPLER, MALE/FLAT . . . . . . . . . 1
ADAP -8ORM -10JICM STR . . . . . . 2
TUBE CUSHION, DBL 3/4” DIA . . . 4
TOP PLATE -TWIN WIDE . . . . . . . . 1
907878/DP0208
Hydraulics
DL Series Dynalift
(Four-Section Boom)
35
36
37 38
39
24
33
32
31
25
26
34
30
43
42
29
2
1
28
20 23 22
40
41
27
21
20 19
3
15
4
5
6
17
16
15
18
7
8
14
9
6
13
12
11
10
907878/DP0208
328
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
(Four-Section Boom)
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10a
11a
12
13
14
15
16
17
18
19
20
21
22
23
24
25
L443011
L71031
L71032
L69832
L69833
L50235
L69832
L69832
L71035
NSS
NSS
L444011
L63720
L71043
L63719
L50143
L50884
L71421
L71104
L520004
L63717
L63715
L50877
L50486
L71042
PRINTED IN U.S.A.
Description
Qty.
Req.
ADAP-10JICM BLKHD 90 . . . . . . . . 2
OUTER REAR AUX. TUBE . . . . . . 1
OUTER REAR AUX. TUBE . . . . . . . 1
DOUBLE TUBE CLAMP . . . . . . . . . 1
CLAMP TOP PLATE . . . . . . . . . . . . 1
5/16”-18X1-1/4” BOLT . . . . . . . . . . . 2
DOUBLE TUBE CLAMP . . . . . . . . . 1
CLAMP TOP PLATE . . . . . . . . . . . . 1
OUTER FRONT AUX. TUBE. . . . . . 2
MALE COUPLER . . . . . . . . . . . . . . 1
FEMALE COUPLER . . . . . . . . . . . . 1
ADAP -8ORM -10JICM STR . . . . . . 2
TWIN HOSE CUSHION .88 . . . . . AR
HOSE ASY. -8X20 . . . . . . . . . . . . . . 2
LOCKWASHER 5/16 . . . . . . . . . . . . 2
CAPSCREW 5/16-18X2-1/4 . . . . . . 2
TWIN HOSE CUSHION .69 . . . . . . 2
5/16”-18X4-1/2” STUD . . . . . . . . . . 2
5/16” NYLON INSERT NUT . . . . . . 4
NARROW TWIN TOP PLATE . . . . . 1
5/16-18”X2-1/4” STUD . . . . . . . . . . 2
1/4-20”X5/8” BOLT . . . . . . . . . . . . . 5
VINYL CLAMP . . . . . . . . . . . . . . . . 10
Ref.
No.
Part
No.
26
27
28
29
30
31
32
33
34b
35
36
37
38
39
40
41
42
43
L71040
L71041
L71046
L99134
L50056
L71747
L71705
L71748
L51035
L71390
L40347
L10057
L71016
L50157
L71389
L71010
L71014
L71213
L71347
a
b
hoses requires hose replacement kit L500438. Kit
329
Description
Qty.
Req.
INNER TUBE . . . . . . . . . . . . . . . . . . 1
INNER TUBE . . . . . . . . . . . . . . . . . . 1
HOSE ASY. -8X290 . . . . . . . . . . . . . 2
HOSE SLEEVE . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
CLAMP BOTTOM . . . . . . . . . . . . . . 1
CLAMP TOP . . . . . . . . . . . . . . . . . . 1
TOP PLATE . . . . . . . . . . . . . . . . . . . 1
5/16”-18X2” BOLT . . . . . . . . . . . . . . 1
HOSE ASY. -8X248 . . . . . . . . . . . . . 1
ADAP -8JICM BLKHD 90 . . . . . . . . 2
GREASE ZERK 90 1/4-28. . . . . . . . 2
PLAIN WASHER 3/4 . . . . . . . . . . . . 2
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
PIN. . . . . . . . . . . . . . . . . . . . . . . . . . 1
HOSE GUIDE . . . . . . . . . . . . . . . . . 1
907878/DP0208
Hydraulics
DL Series Dynalift
Hydraulic / Transmission Cooler Group
FRONT
2
1
3
3
20
4
17
19
16
4
18
7
15
6
5
13
14
8
12
11
9
10
907878/DP0208
330
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18a
19
20
Part
No.
Description
102279
101992
L445001
L51621
L50056
L47212
650486
102280
101836
101835
650484
L41770
L51590
102110
102072
102289
102073
L70083
L445011
Qty.
Req.
Ref.
No.
COOLER, HYD./TRANS.. . . . . . . . . 1
COOLER LATCH . . . . . . . . . . . . . . 1
ADAP, -12ORM -12JICM 90 DEG . . 2
ADAP -16ORM -16JICM 90DEG. . . 2
5/16”-18 FLARE NUT . . . . . . . . . . . 1
CLAMP, VINYL- 3/8” . . . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . . 1
PIN, COOLER HINGE . . . . . . . . . . . 1
HOC TUBE . . . . . . . . . . . . . . . . . . . 1
TOC TUBE. . . . . . . . . . . . . . . . . . . . 1
5/16”-18X1/2” BOLT . . . . . . . . . . . . 1
CLAMP, VINYL-3/4” . . . . . . . . . . . . . 1
ADAP, -16ORM -16JICM . . . . . . . . . 1
HOSE, -12 A12/DL12 32” . . . . . . . . 1
VALVE, COLD START BY-PASS . . . 1
CHECK VALVE . . . . . . . . . . . . . . . . 1
ADAP, -16ORM -16ORM . . . . . . . . . 1
HOSE -12 A12/A12 35” . . . . . . . . . . 1
ADAP, -16ORM -16JICM 45 DEG . . 1
HOSE -16 A16/DS16 . . . . . . . . . . . . 1
Note b and d 84” long
Note c and d 74” long
Note e 78” long
HOSE, -16 A16/A20 30” . . . . . . . . . 1
L69938
102258
105167
102111
Part
No.
Description
Qty.
Req.
a
Earlier units with this style cooler used a 90 degree
fitting; part number L445001 (same as item 3).
b
Used when item 18 is a 90 degree fitting.
c
Used when item 18 is a 45 degree fitting.
d
e
Usage Table
Hose Locator
Ref
No.
From Port
To Port
19
20
17
14
LOWER PORT - COLD START RELIEF VALVE
UPPER PORT - COLD START RELIEF VALVE
COOLER UPPER PORT - LEFT SIDE
COOLER UPPER PORT - RIGHT SIDE
V40 VALVE “OUT” (FRONT RIGHT PORT)
HYDRAULIC FILTER “IN”
TRANSMISSION LOWER PORT
TRANSMISSION UPPER PORT
PRINTED IN U.S.A.
331
907878/DP0208
Hydraulics
DL Series Dynalift
FRONT
1
23
2
3
13
4
22
21
20
5
6
7
8
19
9
18
10
3
11
12
17
4
13
15
16
907878/DP0208
14
11
332
PRINTED IN U.S.A.
DL Series Dynalift
Hydraulics
Ref.
No.
Part
No.
01
L70400
02
03
04
05
06
07
08
09
10
11
L51621
L50061
L450002
L50141
L50228
L69938
L70497
L51590
L50403
L50145
Description
Qty.
Req.
COOLER LATCH WELDMENT . . . . 1
(Includes item 22)
ADAP -16ORM -16JICM 90DEG. . . 1
3/8-16 FLARE NUT . . . . . . . . . . . . . 4
COOLER, 4FPI . . . . . . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . . 4
5/16-18X1/2” BOLT . . . . . . . . . . . . . 4
HOSE -16 A16/DS16 84”. . . . . . . . . 1
HOSE -16 A20/DL16 30” . . . . . . . . . 1
3/8-16X1-1/4” BOLT . . . . . . . . . . . . 2
3/8” FLAT WASHER . . . . . . . . . . . . 6
Ref.
No.
Part
No.
12
13
14
15
16
17
18
19
20
21
22
23
L70394
L520005
L69465
L70392
L50367
L64853
L70083
L70087
L61092
L68110
L70395
L68128
Description
Qty.
Req.
COOLER LOWER MOUNT . . . . . . . 1
3/8-16 LOCK NUT . . . . . . . . . . . . . . 4
HINGE . . . . . . . . . . . . . . . . . . . . . . . 2
COOLERS MOUNT PLATE. . . . . . . 1
3/8-16X1” BOLT. . . . . . . . . . . . . . . . 4
HOSE -12 A12/A12 35” . . . . . . . . . . 1
HOSE -12 A12/DL12 44” . . . . . . . . . 1
ADAP -16ORM - 12JICM 90 DEG . 1
KNOB. . . . . . . . . . . . . . . . . . . . . . . . 1
COOLER LATCH BAR . . . . . . . . . . 1
Usage Table
Hose Locator
Ref
No.
From Port
To Port
07
08
18
19
INNER COOLER UPPER PORT
INNER COOLER LOWER PORT
OUTER COOLER LOWER PORT
OUTER COOLER UPPER PORT
V40 VALVE “OUT” (FRONT RIGHT PORT)
HYDRAULIC FILTER “IN”
TRANSMISSION LOWER PORT
TRANSMISSION UPPER PORT
PRINTED IN U.S.A.
333
907878/DP0208
Hydraulic Components
DL Series Dynalift
Flow Divider
1
2
FRONT
T
IN
Ref.
No.
Part
No.
00
L70229
01
L99928
L99929
907878/DP0208
Description
Qty.
Req.
FLOW DIVIDER. . . . . . . . . . . . . . . . 1
PRESSURE REGULATOR . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
02
L99927
L99925
334
Description
Qty.
Req.
RELIEF VALVE . . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Joystick Disengage Valve
1
2
3
4
Ref.
No.
Part
No.
01
L71733
02
L99910
L99911
PRINTED IN U.S.A.
Description
Qty.
Req.
JOYSTICK DISENGAGE VALVE . . 1
3-WAY 2 POSITION VALVE . . . . . . 1
(Includes item 4)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
03
04
L99908
NSS
335
Description
Qty.
Req.
COIL/WEATHERPAK 12VDC . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
SAHR Valve (Later)
6
2
T
AI
P1
3
4
5
1
Ref.
No.
Part
No.
00
L71707
01
L99910
02
03
L99911
L99919
L99925
L99912
L99911
907878/DP0208
Description
Qty.
Req.
SAHR/ACCUM CHARGE VALVE . . 1
(includes items 1-5)
(Includes item 6)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
NEEDLE VALVE . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
(Includes item 6)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
04
05
L99908
NSS
06
L70008
336
Description
Qty.
Req.
NUT, 1/2”-20 THIN. . . . . . . . . . . . . . 1
(Included with items 1 and 3)
PRESSURE SWITCH . . . . . . . . . . . 1
(not included with valve)
PRINTED IN U.S.A.
DL Series Dynalift
SAHR Valve (Early)
6
3
T
AI
Park Brake
Solenoid
4
P1
1
2
5
Ref.
No.
Part
No.
01
L69395
02
L99912
L99911
PRINTED IN U.S.A.
Description
Qty.
Req.
SAHR/ACCUM CHARGE VALVE . . 1
(Includes item 5)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
03
04
05
L99919
L99925
L99908
NSS
06
L70008
337
Description
Qty.
Req.
NEEDLE VALVE . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
NUT, 1/2”-20 THIN. . . . . . . . . . . . . . 1
PRESSURE SWITCH . . . . . . . . . . . 1
(not included with valve)
907878/DP0208
DL Series Dynalift
Steer Select Valve
1
2
Ref.
No.
00
01
02
Part
No.
L69747
210018
NSS
907878/DP0208
Description
Qty.
Req.
STEER SELECT VALVE, COMPL. . 1
(Includes items 1and 2)
WEATHER PAK VALVE. . . . . . . . . . 1
MANIFOLD . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
00
L68711
338
Description
Qty.
Req.
-- ITEMS NOT SHOWN -WIRE HARNESS . . . . . . . . . . . . . . 2
(connects wire leads to frame wiring)
PRINTED IN U.S.A.
DL Series Dynalift
Level Valve
1
2
3
4
5
6
P
LSB
6
T
7
Ref.
No.
Part
No.
00
L70230
01
02
L99921
L99907
NSS
03
04
L99908
L99920
L99925
PRINTED IN U.S.A.
Description
Qty.
Req.
LEVEL VALVE . . . . . . . . . . . . . . . . . 1
(Includes all parts shown)
VALVE, WEATHERPAK . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 2
COIL, WEATHERPAK 12VDC . . . . . 1
2 WAY SOLENOID VALVE . . . . . . . 1
(Includes item 2)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
05
06
07
L99917
L99923
L99922
339
Description
Qty.
Req.
PLUG -4 NWD . . . . . . . . . . . . . . . . . 1
SHUTTLE VALVE . . . . . . . . . . . . . . 2
PLUG -6 NWD . . . . . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Main Valve - (HydroControl)
11
7
9
12
6
10
7
13
8
8
5
9
15
12
4
16
14
3
2
18
17
1
FRONT
907878/DP0208
340
PRINTED IN U.S.A.
DL Series Dynalift
Main Valve - (HydroControl)
Ref.
No.
Part
No.
00
105159
01
105557
103054
02
103063
103057
03
103066
103058
04
103067
103056
05
103065
103061
06
105556
Description
Qty.
Req.
V40 VALVE COMPLETE ASSY. . . . 1
(without auxiliary hydraulics section)
COMPLETE SEAL KIT (not shown) 1
INLET SECTION . . . . . . . . . . . . . . . 1
SECTION SEAL KIT (not shown) . . 1
WORK SECTION (lift) . . . . . . . . . . . 1
(includes items 8,9,14,15)
WORK SECTION (tilt) . . . . . . . . . . . 1
WORK SECTION (boom in/out) . . . 1
OUTLET SECTION . . . . . . . . . . . . . 1
(includes item 7)
TIE ROD KIT (3 section valve) . . . . 4
(includes two nuts and washers)
Ref.
No.
Part
No.
07
08
09
10
11
12
13
14
15
16
17
18
103068
103046
103052
L99903
103048
103045
104320
103047
103053
103050
103049
103051
Description
Qty.
Req.
PLUG . . . . . . . . . . . . . . . . . . . . . . . . 2
ANTI-CAVITATION VALVE . . . . . . AR
CHECK VALVE . . . . . . . . . . . . . . . AR
WORK PORT RESTRICTOR . . . . . 1
ANTI-SHOCK VALVE (210 bar). . . . 1
COMBINATION VALVE (210 bar) . . 2
CHECK VALVE . . . . . . . . . . . . . . . . 1
PLUG KIT . . . . . . . . . . . . . . . . . . . . 1
CONTROL KIT . . . . . . . . . . . . . . . AR
PLUG KIT . . . . . . . . . . . . . . . . . . . . 1
PILOT RELIEF VALVE (210 bar). . . 1
PLUG KIT, 1-5/16”-12 UNF . . . . . . . 1
Usage Table - Main Control Valve
PRINTED IN U.S.A.
341
907878/DP0208
DL Series Dynalift
Main Valve - (Gresen/Parker)
INLET
1
OUT
IN
2
5
6
4
3
7
17
17
SECTION 1
LIFT
5
8
9
9
3
7
17
17
SECTION 2
TILT
10
12
15
6
11
7
16
5
3
17
17
14
13
SECTION 3
EXTEND
OUTLET
COVER
907878/DP0208
342
PRINTED IN U.S.A.
DL Series Dynalift
Main Valve - (Gresen/Parker)
Ref.
No.
Part
No.
00
L69475
01
02
L99895
L99896
L99897
L99086
L98894
L97358
L97359
L99085
L99898
L97359
L99084
L98894
L99892
03a
04
05a
06
07a
08
09
Description
Qty.
Req.
V40 VALVE COMPLETE ASSY.
(without Auxiliary hydraulics)
COVER HOUSING (INLET) . . . . . . 1
RELIEF CARTRIDGE . . . . . . . . . . . 1
RELIEF SEAL KIT . . . . . . . . . . . . . 1
HRO ACTUATOR “A” PORT . . . . . . 3
SEAL KIT, ACTUATOR . . . . . . . . AR
NO RELIEF PLUG. . . . . . . . . . . . . . 1
PLUG SEAL KIT . . . . . . . . . . . . . . . 1
LOAD CHECK PLUG KIT . . . . . . . . 3
NO RELIEF CARTRIDGE . . . . . . . . 2
PLUG SEAL KIT . . . . . . . . . . . . . . . 1
HRO ACTUATOR “B” PORT . . . . . . 3
WORK SECT. NO. 1 ASY. . . . . . . . . 1
PLUG SEAL KIT . . . . . . . . . . . . . . . 1
L97362
L97359
Extend
Ref.
No.
Part
No.
Description
Qty.
Req.
10
L99893
11
12
13
L98029
L97359
L99903
L99894
14
15
16
17
L99831
L99899
L99905
L500300
00
L99904
a
Units with Auxiliary hydraulics use a quantity of 4.
WORK SECT. NO. 2 ASY . . . . . . . . 1
(Includes items 3, 5, 7 and 9)
PLUG SEAL KIT . . . . . . . . . . . . . . . 1
WORK PORT RESTRICTOR . . . . . 1
WORK SECT. NO. 3 ASY . . . . . . . . 1
(Includes items 3, 5, 6, 7, 11 and 12)
PLUG -16. . . . . . . . . . . . . . . . . . . . . 2
COVER HOUSING (OUTLET) . . . . 1
SECTION SEAL KIT . . . . . . . . . . . . 1
DUST BOOT, RUBBER . . . . . . . . AR
-- ITEMS NOT SHOWN -STUD KIT, 3 SECTION VALVE . . . . 1
Retract
Back
B
Forward
Section 4
Auxiliary
A
Raise
Lower
Standard on
(Four-Section Boom)
Optional on
OUT
IN
Section 3
Boom Extend
FRONT
Section 1
Lift
Section 2
Tilt
PRINTED IN U.S.A.
343
907878/DP0208
DL Series Dynalift
Auxiliary Hydraulics Valve Section
3
4
2
3
5
2
FRONT
1
Ref.
No.
Part
No.
Description
Qty.
Req.
01
105165
02a
03c
04c
05b
103053
103086
103052
103087
00
103059
a
Includes outer caps, orings, bolts, plug and
internal spool spring for this work section, does
not include orings for valves/plugs or the spool.
b
Items included with seal kit are not shown in detail.
c
Seals/orings for this valve are not sold individually,
however they are included with the work section
seal kit where this valve is used.
907878/DP0208
Ref.
No.
Part
No.
Description
Qty.
Req.
AUXILIARY HYD WORK SECT. . . .1
HYD. CONTROL KIT . . . . . . . . . . . .2
ANTISHOCK VALVE . . . . . . . . . . . .1
CHECK VALVE . . . . . . . . . . . . . . . .1
SEAL KIT . . . . . . . . . . . . . . . . . . . . .1
-- ITEMS NOT SHOWN -TIE ROD KIT (4 section valve) . . . .4
(includes two nuts and washers)
344
PRINTED IN U.S.A.
DL Series Dynalift
Auxiliary Hydraulic Valve Section
7
6
2
1
B
A
3
3
8
5
Ref.
No.
Part
No.
01
L66576
02
03
L99085
L97362
L97359
L99086
L98894
L99084
L98894
L99093
L99905
L500300
04
05
06
07
08
4
Description
WORK SECTION (AUX) Kit . . . . . . 1
LOAD CHECK PLUG KIT . . . . . . . . 1
PLUG SEAL KIT . . . . . . . . . . . . . . . 1
SEAL KIT, ACTUATOR . . . . . . . . . . 1
SEAL KIT, ACTUATOR . . . . . . . . . . 1
STUD KIT, 4 SECTION VALVE . . . . 1
SECTION SEAL KIT . . . . . . . . . . . . 1
DUST BOOT. . . . . . . . . . . . . . . . . AR
Items in seal kits are not shown
PRINTED IN U.S.A.
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
345
907878/DP0208
DL Series Dynalift
Pilot Manifold
Dual-Function (Two-Button) Joystick Option
4
3
1
2
2
Ref.
No.
Part
No.
L69467
01
L99910
02
L99911
L99909
L99911
907878/DP0208
Description
1
Qty.
Req.
PILOT APPLY MANIFOLD . . . . . . . . a
(Includes all items except item 5)
VALVE, 3-WAY 2 POSITION . . . . . . 2
(Includes item 4)
SEAL KIT, 3-WAY VALVE . . . . . . . . 2
(Includes item 4)
5
Ref.
No.
Part
No.
03
04
L99908
NSS
05
L71342
a
Units equipped with Auxiliary Hydraulics will use
(2) L69467 Pilot Apply Manifolds
346
Description
Qty.
Req.
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 4
WIRE HARNESS, TILT CONTROL . 1
PRINTED IN U.S.A.
DL Series Dynalift
Pilot Manifold
Tri-Function (Four-Button) Joystick Option
2
1
B
T
3
P
A
4
7
6
5
FRONT
Ref.
No.
Part
No.
L71339
01
02
03
L500745
L99911
L99917
L500746
L99924
PRINTED IN U.S.A.
Description
Qty.
Req.
PILOT APPLY MANIFOLD . . . . . . . . a
(Includes all items except item 7)
PRESSURE CONTROL . . . . . . . . . 2
SEAL KIT . . . . . . . . . . . . . . . . . . . . 2
PLUG -4 NWD STYLE . . . . . . . . . . 1
VALVE, 2 WAY . . . . . . . . . . . . . . . . 1
(Includes item 6)
SEAL KIT, 2 WAY VALVE . . . . . . . . 1
Ref.
No.
Part
No.
04
L99910
05
06
L99911
L99908
NSS
07
L71343
a
Units equipped with Auxiliary Hydraulics will use
(2) L71339 Pilot Apply Manifolds
347
Description
Qty.
Req.
(Includes item 6)
NUT . . . . . . . . . . . . . . . . . . . . . . . . . 3
WIRE HARNESS, TILT CONTROL . 1
907878/DP0208
DL Series Dynalift
Radio Remote Manifold (Option)
3
2
2
1
UP
IN
INL
OUT
DOW
N
4
907878/DP0208
348
PRINTED IN U.S.A.
DL Series Dynalift
Radio Remote Manifold (Option)
Ref.
No.
Part
No.
00
103413
01
103508
103511
103510
103509
103512
02
03
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE VALVE. . . . . . . . . . . . . 1
(includes all items shown and listed)
2/4 WAY SOLENOID VALVE . . . . . . 1
SEAL KIT FOR VALVE . . . . . . . . . . 1
12 VDC COIL (DIN CONN.) . . . . . . 5
PROPORTIONAL PRESS. VALVE . 4
SEAL KIT FOR VALVE . . . . . . . . AR
Ref.
No.
Part
No.
04
NSS
00
103514
103513
349
Description
Qty.
Req.
MANIFOLD . . . . . . . . . . . . . . . . . . . 1
-- ITEMS NOT SHOWN -SHUTTLE VALVE . . . . . . . . . . . . . . 4
SEAL KIT FOR VALVE . . . . . . . . AR
907878/DP0208
DL Series Dynalift
Outrigger V20 Valve
1
INLET
COVER
2
3
OUTLET
COVER
4
8
B
A
6
6
7
5
9
10
907878/DP0208
350
PRINTED IN U.S.A.
DL Series Dynalift
Outrigger V20 Valve
Ref.
No.
01
02
03
04
05a
Part
No.
L70528
L500128
L500129
L96580
L500133
L500126
L500135
L98894
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE VALVE ASY. . . . . . . . . 1
INLET COVER HOUSING. . . . . . . . 1
RELIEF SEAL KIT . . . . . . . . . . . . . 1
OUTLET COVER HOUSING. . . . . . 1
STUD ASY. KIT . . . . . . . . . . . . . . . . 1
06
07a
08
09a
10
L500132
L500134
L98894
L500131
L500127
L500300
a
Items in seal kits are not shown
351
Description
Qty.
Req.
LOAD CHECK PLUG . . . . . . . . . . . 4
WORK SECTION (includes 5-7) . . . 2
SECTION SEAL KIT . . . . . . . . . . . . 1
DUST BOOT. . . . . . . . . . . . . . . . . AR
907878/DP0208
DL Series Dynalift
Outrigger Pilot Manifold (Early Style)
1
NOTE: early units
can be identified by
the plastic cap nut.
2
3
Components do NOT
interchange between
“Early” and “Later”
manifolds.
4
P
1
T
2
3
4
Ref.
No.
Part
No.
103878
01
L500243
907878/DP0208
Description
Qty.
Req.
COMPLETE. VALVE ASSEMBLY . . 1
WEATHERPROOF NUT KIT . . . . . . 4
(Includes nut and 2 o-rings)
Ref.
No.
Part
No.
02
03
L99908
L99998
04
L70651
352
Description
Qty.
Req.
WEATHERPAK COIL 12VDC . . . . . 4
VALVE . . . . . . . . . . . . . . . . . . . . . . . 4
(Includes item 1)
OUTRIGGER WIRE HARNESS . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Outrigger Pilot Manifold (Later Style)
1
NOTE: later units
can be identified by
the steel nut.
2
3
Components do NOT
interchange between
“Early” and “Later”
manifolds.
4
Ref.
No.
Part
No.
103878
01
NSS
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE. VALVE ASSEMBLY . . 1
NUT, SOLENOID VALVE . . . . . . . . . 4
Ref.
No.
Part
No.
02
03
104016
L99912
04
L70651
353
Description
Qty.
Req.
E-COIL 12VDC . . . . . . . . . . . . . . . . 4
VALVE . . . . . . . . . . . . . . . . . . . . . . . 4
(Includes item 1)
OUTRIGGER WIRE HARNESS . . . 1
907878/DP0208
DL Series Dynalift
Tri-Function (Four-Button) Joystick Controller
1
12
7
8
2
9
3
4
10
3
5
11
6
907878/DP0208
354
PRINTED IN U.S.A.
DL Series Dynalift
Tri-Function (Four-Button) Joystick Controller
Ref.
No.
Part
No.
00
01
02
03
04
05
06
07
08
09
L71346
104083
L500371
L62761
L500688
L500656
L500689
L500652
L500692
L500690
L500691
104223
Description
Qty.
Req.
Ref.
No.
Part
No.
JOYSTICK 4-BUTTON/TRIGGER. . 1
Note a
Note b
HANDLE W/4 BUTTONS . . . . . . . . 1
WIRE CONNECTOR . . . . . . . . . . . . 8
NUT M10 UNI . . . . . . . . . . . . . . . . . 2
RUBBER BOOT . . . . . . . . . . . . . . . 1
SELECTOR DISC . . . . . . . . . . . . . . 1
UNIVERSAL JOINT . . . . . . . . . . . . . 1
SPINDLE GUIDE ASSEMBLY. . . . . 4
HPV SPINDLE 10mm . . . . . . . . . . . 4
PILOT SPRING PACK . . . . . . . . . . . 4
Note a - (CO94 Springs)
Note b - (CO59 Springs)
10
11c
12
NSS
L500653
104304
b
355
Qty.
Req.
BODY ASSEMBLY. . . . . . . . . . . . . . 1
SEAL REPAIR KIT . . . . . . . . . . . . . 1
BEZEL, JOYSTICK . . . . . . . . . . . . . 1
a
c
PRINTED IN U.S.A.
Description
Items included in the seal kit are not shown.
907878/DP0208
DL Series Dynalift
Dual-Function (Two-Button) Joystick Controller
(Later Style - Gray Valve Body)
1
11
2
3
6
2
4
7
8
10
5
9
GRAY
VALVE
BODY
907878/DP0208
356
PRINTED IN U.S.A.
DL Series Dynalift
(Later Style - Gray Valve Body)
Ref.
No.
Part
No.
00
01
02
03
04
05
06
07
08
L71366
104084
L500357
L500688
L500656
L500689
L500652
L500692
L500690
L500691
104223
Description
Qty.
Req.
Ref.
No.
Part
No.
JOYSTICK 2 BUTTON . . . . . . . . . . 1
Note a (gray valve body)
Note b (gray valve body)
HANDLE W/2 BUTTONS . . . . . . . . 1
NUT M10 UNI . . . . . . . . . . . . . . . . . 2
RUBBER BOOT . . . . . . . . . . . . . . . 1
SELECTOR DISC . . . . . . . . . . . . . . 1
UNIVERSAL JOINT . . . . . . . . . . . . . 1
SPINDLE GUIDE ASSEMBLY. . . . . 4
HPV SPINDLE 10mm . . . . . . . . . . . 4
PILOT SPRING PACK C094 . . . . . . 4
Note a - (C094 Springs)
Note b - (CO59 Springs)
09
10c
11
NSS
L500653
104304
b
357
Qty.
Req.
BODY ASSEMBLY. . . . . . . . . . . . . . 1
SEAL REPAIR KIT . . . . . . . . . . . . . 1
BEZEL, JOYSTICK . . . . . . . . . . . . . 1
a
c
PRINTED IN U.S.A.
Description
907878/DP0208
DL Series Dynalift
(Early Style - Black Valve Body)
1
8
5
2
7
3
6
4
BLACK
VALVE
BODY
907878/DP0208
358
PRINTED IN U.S.A.
DL Series Dynalift
(Early Style - Black Valve Body)
Ref.
No.
Part
No.
01a
02
03
04
05
06
L500361
L99961
L99962
L99963
L99964
L99965
Description
Qty.
Req.
HANDLE W/ROCKER SWITCH . . . 1
RUBBER BOOT . . . . . . . . . . . . . . . 1
SELECTOR SPRING (DISC) . . . . . 1
CARDAN JOINT . . . . . . . . . . . . . . . 1
RETAINER RING. . . . . . . . . . . . . . . 1
PLUNGER KIT. . . . . . . . . . . . . . . . . 4
Ref.
No.
Part
No.
07
L71415
L51034
L500357
08b
a
b
Description
Qty.
Req.
JOYSTICK HANDLE ADAPTER . . . 1
M10X1.5 JAM NUT (not shown) . . . 1
HANDLE W/2 BUTTONS . . . . . . . . 1
Replacement Kit.
Requires item # 7 L71415 adapter and L51034
jam nut.
Usage Table
DL6L SN 25647 and before; with black valve body
DL6H SN 20924 and before; with black valve body
PRINTED IN U.S.A.
359
907878/DP0208
DL Series Dynalift
Stabilizer Cylinder Manifold Group
1
2
J
3
M
E
5
4
D
K
6
B
L
7
8
9
7
STABILIZER CYLINDER
907878/DP0208
360
PRINTED IN U.S.A.
DL Series Dynalift
Stabilizer Cylinder Manifold Group
Ref.
No.
Part
No.
00
01
02
03
04
L66885
L71166
L50458
L60986
L69997
L99913
L99916
05
06
07
08
09
L99941
L500252
L99914
L500243
L445002
L69775
L70495
L97889
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE VALVE ASSEMBLY. . . 1
Note a (Includes items 2-6 and 9)
Note b (Includes items 2-6 and 9)
5/16”-18X3-3/4” BOLT . . . . . . . . . . . 2
PLUG -4ORM . . . . . . . . . . . . . . . . . 3
VALVE, 2WAY(Inc. items #4-6) . . . . 2
CARTRIDGE (ONLY). . . . . . . . . . . . 2
SEAL KIT, CARTRIDGE . . . . . . . . . 1
Note a
Note b
SEAL KIT, COIL (fits both PN’s)
NUT (Included with item 5). . . . . . . 2
ADAP -8ORM -8JICM 90. . . . . . . . . 4
TUBE, STABILIZER CYL. . . . . . . . . 2
COUNTER BAL. VALVE 3700PSI . . 2
CBV SEAL KIT . . . . . . . . . . . . . . . . 1
Ref.
No.
a
b
361
Part
No.
Description
Qty.
Req.
DL12H SN ALL
907878/DP0208
DL Series Dynalift
Frame Level Cylinder
1
3
2
4
5
6
10
9
8
7
11
12
14
13
907878/DP0208
362
PRINTED IN U.S.A.
DL Series Dynalift
Frame Level Cylinder
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
L63015
L63016
L10057
L98503
L99405
L98550
L98507
L98457
L99857
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE ASSEMBLY
BUSHING 2.0X2.25X2.5” . . . . . . . . 1
1/4-28 GREASE ZERK STR . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
1-1/4-12 UNF LOCKNUT. . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
HEAD GLAND CAP. . . . . . . . . . . . . 1
5/16-18X1/4” SET SCREW . . . . . . 1
Ref.
No.
Part
No.
09
10
11
12
13a
14
L98509
L10465
L64367
L70495
L97889
L98506
NSS
a
363
Description
Qty.
Req.
OIL LINE TUBE ASSEMBLY . . . . . . 1
1/4-28 GREASE ZERK . . . . . . . . . . 1
BUSHING 2.0X2.25X2.0” . . . . . . . . 1
COUNTER BALANCE VALVE . . . . . 2
SEAL KIT (CBV) . . . . . . . . . . . . . . . 1
CYLINDER SEAL KIT . . . . . . . . . . . 1
CYLINDER TUBE WELDMENT . . . 1
907878/DP0208
DL Series Dynalift
Stabilizer Cylinder
1
2
4
5
4
3
7
6
8
9
3
907878/DP0208
364
PRINTED IN U.S.A.
DL Series Dynalift
Stabilizer Cylinder
Ref.
No.
01
02
03
04
05
Part
No.
L70358
L69138
L99934
L99937
L99936
L99938
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
BUSHING . . . . . . . . . . . . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 2
ROD SPACER . . . . . . . . . . . . . . . . . 2
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
06
07
08
09a
L69774
NSS
L99935
L99942
a
365
Description
Qty.
Req.
BUSHING . . . . . . . . . . . . . . . . . . . . 2
TUBE WELDMENT . . . . . . . . . . . . . 1
CYLINDER ROD . . . . . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
Lift Cylinder
2
1
7
3
6
5
4
10
8
9
12
11
13
907878/DP0208
366
PRINTED IN U.S.A.
DL Series Dynalift
Lift Cylinder
Ref.
No.
Part
No.
L69125
L69135
01
02
03
04
L69564
L69565
L10465
L99861
L99853
L69142
L99863
L99856
05
L99862
L99854
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE ASSEMBLY (RIGHT) . 1
Note a
Note b
COMPLETE ASSEMBLY (LEFT). . . 1
Note a
Note b
1/4-28 GREASE ZERK . . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
Note a
Note b
BUSHING (ROD END) . . . . . . . . . . 1
HEAD GLAND CAP. . . . . . . . . . . . . .
Note a
Note b
HEAD GLAND . . . . . . . . . . . . . . . . . 1
Note a
Note b
Ref.
No.
Part
No.
06
07
08
09
10
11C
L99860
L99851
L99122
L99857
L70502
L96838
L69138
Description
Qty.
Req.
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
Note a
Note b
1-3/4”-12 UNF LOCKNUT . . . . . . . . 1
5/16-18X1/4” SET SCREW . . . . . . . 1
CBAL VALVE . . . . . . . . . . . . . . . . . . 1
CB VALVE SEAL KIT . . . . . . . . . . . 1
BUSHING (BASE END). . . . . . . . . . 1
Note a
Note b
PLUG -4 . . . . . . . . . . . . . . . . . . . . . 1
12
13
L99859
L99849
L99917
NSS
a
b
Used on model DL6
Used on models DL8, DL10 and DL12
*
367
907878/DP0208
DL Series Dynalift
Slave Cylinder
1
2
3
8
7
5
4
9
6
10
11
12
13
Proximity Sensor Tab and
Rod Slide Tab
are used on left hand
cylinders only
907878/DP0208
368
PRINTED IN U.S.A.
DL Series Dynalift
Slave Cylinder
Ref.
No.
Part
No.
L69149
L69139
01
02
03
04
L70251
L70240
L10465
L99865
L99871
L63018
L98547
L99872
05
06
L99866
L98528
L99857
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE ASSEMBLY (RIGHT) . 1
Note a
Note b
COMPLETE ASSEMBLY (LEFT). . . 1
Note a
Note b
1/4-28 GREASE ZERK STR . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
Note a
Note b
BUSHING (ROD END) . . . . . . . . . . 1
HEAD GLAND CAP. . . . . . . . . . . . . 1
Note a
Note b
HEAD GLAND . . . . . . . . . . . . . . . . . 1
Note a
Note b
5/16-18X1/4” SET SCREW . . . . . . 1
Ref.
No.
Part
No.
07
08a
08b
09
10
11
L99864
L99870
L500751
L99405
L10057
L63017
Description
Qty.
Req.
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
Note a
Note b
1-3/8-12 UNF LOCKNUT. . . . . . . . . 1
1-1/4-12 UNF LOCKNUT. . . . . . . . . 1
1/4-28 GREASE ZERK 90 DEG . . . 1
BUSHING (BASE END). . . . . . . . . . 1
Note a & d
Note b & d
BUSHING (ROD SLIDE TAB) . . . . . 1
12
13c
L99868
L99869
NSS
L48179
a
b
c
d
Used on high boom - all models
Used on low boom - all models
Used on cylinders L70251 and L70240
369
907878/DP0208
DL Series Dynalift
Tilt Cylinder
2
1
Low boom rod weldment and
spherical bearing are shown.
8
7
6
5
3
9
4
10
14
12
13
11
907878/DP0208
370
PRINTED IN U.S.A.
DL Series Dynalift
Tilt Cylinder
Ref.
No.
Part
No.
L69144
L69751
01
L99889
L99891
02
03
04
05
06
L99886
L99890
L99887
L99879
L99888
L99852
PRINTED IN U.S.A.
Description
Qty.
Req.
Note a
Note b
BUSHING . . . . . . . . . . . . . . . . . . . . 1
Note a (Bushing)
Note b (Spherical bearing)
ROD WELDMENT . . . . . . . . . . . . . . 1
Note a (Includes bushing L99889)
Note b
HEAD GLAND CAP. . . . . . . . . . . . . 1
5/16-18X5/16” SET SCREW . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
THRUST WASHER . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
07
08
09
10
11
12
13c
14
L99885
L99122
L69127
L70502
L96838
NSS
L99917
L99883
L10465
a
b
c
Used on high boom - all models.
Used on low boom - all models.
371
Description
Qty.
Req.
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
1-3/4” UNF LOCKNUT. . . . . . . . . . . 1
BUSHING (BASE END). . . . . . . . . . 1
CB VALVE SEAL KIT . . . . . . . . . . . 1
PLUG -4. . . . . . . . . . . . . . . . . . . . . . 1
1/4-28 GREASE ZERK STR . . . . . . 1
907878/DP0208
DL Series Dynalift
Boom Extend Cylinder
3
4
1
10
9
8
2
7
5
6
12
11
907878/DP0208
372
PRINTED IN U.S.A.
DL Series Dynalift
Ref.
No.
01
02
03
Part
No.
L69305
L69136
L69146
L69156
L64367
L10465
L70274
L99943
04
L99880
L99878
L99881
L99882
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
Note a
Note b
Note c
Note d
BUSHING (ROD END) . . . . . . . . . . 1
1/4”-28 GREASE ZERK. . . . . . . . . . 1
CBAL VALVE SEAL KIT . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
Note a
Note b
Note c
Note d
05
06
07
08
09
10
11
12e
L99056
L99879
L99053
L99877
L99875
L99874
NSS
L99873
a
b
c
d
e
40’ Low Boom
40’ High Boom and 42’ Low Boom
42’ High Boom and 44’ Low Boom
44’ High Boom
373
Description
Qty.
Req.
HEAD GLAND CAP. . . . . . . . . . . . . 1
5/16-18X5/16” SET SCREW . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
ROD SPACER . . . . . . . . . . . . . . . . . 1
5/16-18X5/8” SET SCREW . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
(Four-Section Boom)
3
1
7
6
2
5
4
9
8
10
11
907878/DP0208
374
PRINTED IN U.S.A.
DL Series Dynalift
(Four-Section Boom)
Ref.
No.
01
02
03
04
05
Part
No.
L71023
L71024
L10465
L67119
L500752
L500753
L500758
L500754
L500755
PRINTED IN U.S.A.
Description
Qty.
Req.
Note a
Note b
1/4”-28 GREASE ZERK. . . . . . . . . . 2
BUSHING (ROD END) . . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
Note a
Note b
HEAD GLAND . . . . . . . . . . . . . . . . . 1
ROD SPACER . . . . . . . . . . . . . . . . . 1
Note a
Note b
Ref.
No.
Part
No.
06
07
08
09
10
11c
L500757
L99122
L67120
L70274
L99943
NSS
L500262
a
b
c
375
Description
Qty.
Req.
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
1-3/4”-12 UNF LOCKNUT . . . . . . . . 1
BUSHING (BASE END). . . . . . . . . . 1
CBAL VALVE SEAL KIT . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
Outrigger Cylinder
1
2
3
6
5
4
7
8
9
11
10
9
907878/DP0208
376
PRINTED IN U.S.A.
DL Series Dynalift
Outrigger Cylinder
Ref.
No.
01
02
03
04
05
06
Part
No.
L70616
L99989
L10465
L70618
L99991
L99992
L500751
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
ROD WELDMENT . . . . . . . . . . . . . . 1
1/4”-28 GREASE ZERK. . . . . . . . . . 2
BUSHING (ROD END) . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
1-3/8”-12 UNF LOCKNUT . . . . . . . . 1
07
08
09
10
11a
L69138
L99917
L99987
NSS
L99988
a
377
Description
Qty.
Req.
BUSHING (BASE END). . . . . . . . . . 1
PLUG, -40RM . . . . . . . . . . . . . . . . . 1
PO CHECK VALVE . . . . . . . . . . . . . 2
907878/DP0208
DL Series Dynalift
Dynacarrier® Lock Cylinder
1
2
4
5
3
7
6
Ref.
No.
00
01
02
03
04
Part
No.
L71425
NSS
L500725
L500722
L500721
907878/DP0208
Description
Qty.
Req.
COMPLETE ASSEMBLY
DIE SPRING, MED 2X3.69X8 . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
05
06
07a
L500724
L500723
L500726
a
Items included in seal kit are not shown.
378
Description
Qty.
Req.
9/16-18 UNF LOCKNUT . . . . . . . . . 1
CYLINDER ROD . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Swing Carriage Cylinder
1
2
4
5
3
6
2
7
8
Ref.
No.
00
01
02
03
04
05
Part
No.
L63970
L500364
L63593
L500365
L98662
L500367
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
ROD WELDMENT . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . . 2
HEAD GLAND . . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
3/4”-16 LOCKNUT . . . . . . . . . . . . . . 1
06
07a
08
L10465
L99944
NSS
a
379
Description
Qty.
Req.
1/4”-28 GREASE ZERK. . . . . . . . . . 2
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
TUBE WELDMENT . . . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
Rotate Carriage Cylinder
1
2
4
5
3
6
7
2
8
9
907878/DP0208
380
PRINTED IN U.S.A.
DL Series Dynalift
Rotate Carriage Cylinder
Ref.
No.
Part
No.
00
01a
01bc
02
03
04
05a
05bc
06
07d
L61317
L70655
L97768
L500242
L64122
L99074
L97839
L99405
080313
NSS
L97769
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
Note a
Note b and note c
ROD WELDMENT . . . . . . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
1”-14 JAM NUT . . . . . . . . . . . . . . . . 1
1”-14 UNS THIN COL. LOCKNUT . 1
TUBE WELDMENT . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
08a
L64175
L97889
L48868A
L96838
08bc
09
L97767
L500241
a
b
c
d
381
Description
Qty.
Req.
CB VALVE . . . . . . . . . . . . . . . . . . . . 1
CB VALVE SEAL KIT . . . . . . . . . . . 1
CB VALVE (3000 psi) . . . . . . . . . . . 2
CB VALVE SEAL KIT . . . . . . . . . . . 1
HYDRAULIC LINE ASSEMBLY. . . . 1
Note a
Note b and note c
Dynattach - Attachment SN 5483 and before
Dynattach - Attachment SN 5484 and up
Dynacarrier - SN ALL
907878/DP0208
DL Series Dynalift
Fork Shift Carriage Cylinder
1
3
4
2
6
5
Ref.
No.
00
01
02
03
04
Part
No.
L68337
L500763
L500762
L500761
L500367
907878/DP0208
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
ROD WELDMENT . . . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
3/4”-16 UNF LOCKNUT. . . . . . . . . . 1
05
06a
NSS
L500370
a
382
Description
Qty.
Req.
TUBE WELDMENT . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Grapple Cylinder
4
3
2
1
5
7
6
8
4
Ref.
No.
00
01
02
03
04
05
Part
No.
L67248
L98921
080319
NSS
L63593
L98919
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
COMPLETE ASSEMBLY
PISTON . . . . . . . . . . . . . . . . . . . . . . 1
3/4-16 UNF LOCKNUT . . . . . . . . . . 1
BRONZE BUSHING 1X1.25X1.5 . . 2
HEAD GLAND . . . . . . . . . . . . . . . . . 1
06a
L98922
07
NSS
08
L98923
a
Not all items included in the seal kit are shown.
383
Description
Qty.
Req.
SEAL KIT . . . . . . . . . . . . . . . . . . . . . 1
(Includes item 7)
SNAP RING . . . . . . . . . . . . . . . . . . . 1
ROD WELDMENT . . . . . . . . . . . . . . 1
907878/DP0208
DL Series Dynalift
Park Brake Caliper
1
1
Early Style
Later Style
5
2
8
9
4
Seal Kit
6
3
10
7
907878/DP0208
384
PRINTED IN U.S.A.
DL Series Dynalift
Park Brake Caliper
Ref.
No.
Part
No.
01
02
105238
101308
L500941
03
04
05
NSS
NSS
L500942
06
07
08
NSS
NSS
09
10
105271
105270
105261
651719
PRINTED IN U.S.A.
Description
Qty.
Req.
Note a
Note b
BRAKE PAD KIT . . . . . . . . . . . . . . . 1
BOLT (included with item 2) . . . . . . 1
NUT (included with item 2) . . . . . . . 2
URETHANE SPRING KIT . . . . . . . 1
(consists of two urethane bushings)
O-RING (included with item 8) . . . . 2
DISC SPRINGS. . . . . . . . . . . . . . . . 5
SEAL KIT (items in kit not shown). . 1
Note a
Note b
JAMNUT / SLEEVE 3/4”-10 . . . . . . 2
BOLT, 3/4”-10X6” GR8 . . . . . . . . . . 2
Ref.
No.
00
Part
No.
Description
Qty.
Req.
-- ITEMS NOT SHOWN -OVERHAUL KIT . . . . . . . . . . . . . . . 1
105239
Note a
L500940
Note b
(overhaul kit includes items 2-8)
NOTE: Always visually compare the park brake
caliper on your machine with the illustrations on the
facing page before ordering parts.
a
Refer to Illustration on facing page. In most cases,
applies to the following (later style) machines:
b
Refer to Illustration on facing page. In most cases,
applies to the following (early style) machines:
385
907878/DP0208
Attachments
DL Series Dynalift
(With serial number format 00-000-A and Rounded Top of Panel)
7
8
FRONT
WORK PLATFORM
LOCK PINS
(Secures platform
to forks)
6
2
5
RIGHT
LEFT
3
1
4
Ref.
No.
01
02
03
04
05
06
07a
08
Part
No.
103905
103906
103907
103908
103909
100883
105845
076099
907878/DP0208
Description
Qty.
Req.
BASE . . . . . . . . . . . . . . . . . . . . . . . . 1
RIGHT DOOR . . . . . . . . . . . . . . . . . 1
LEFT DOOR . . . . . . . . . . . . . . . . . . 1
FRONT SIDE . . . . . . . . . . . . . . . . . . 1
BACK SIDE . . . . . . . . . . . . . . . . . . . 1
DECAL, PLATFORM RULES . . . . . 2
PIN AND CHAIN ASSY. . . . . . . . . . . 2
HAIRPIN CLIP .148DIAX2-11/16” . . 2
Ref.
No.
Part
No.
00
00
00
103911
101149
103910
a
Chain is welded to platform base.
386
Description
Qty.
Req.
-- ITEMS NOT SHOWN -PIN AND CHAIN KIT (sides) . . . . . . 1
DECAL, FALL HAZARD . . . . . . . . . 2
HARDWARE KIT . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
(With serial number format 00-000-A and Square Top of Panel)
5
6
2
RIGHT
LEFT
3
4
1
FRONT
Ref.
No.
01
02
03
04
05
06
Part
No.
103905
105603
105604
105605
105606
100883
PRINTED IN U.S.A.
Description
Qty.
Req.
BASE . . . . . . . . . . . . . . . . . . . . . . . . 1
RIGHT DOOR . . . . . . . . . . . . . . . . . 1
LEFT DOOR . . . . . . . . . . . . . . . . . . 1
FRONT SIDE . . . . . . . . . . . . . . . . . . 1
BACK SIDE . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
00
00
00
103911
101149
103910
387
Description
Qty.
Req.
-- ITEMS NOT SHOWN -PIN AND CHAIN KIT . . . . . . . . . . . . 1
HARDWARE KIT . . . . . . . . . . . . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
(Attachment SN 10837 thru 11192)
2
3
4
5
8
2
1
7
9
6
Ref.
No.
01
02
03
04
05
Part
No.
100044
100047
100058
100057
100056
100051
907878/DP0208
Description
Qty.
Req.
PWP FRAME . . . . . . . . . . . . . . . . . . 1
GUARD RAIL ASY. . . . . . . . . . . . . . 2
KNOB. . . . . . . . . . . . . . . . . . . . . . . . 2
SPRING . . . . . . . . . . . . . . . . . . . . . . 2
LATCH PIN . . . . . . . . . . . . . . . . . . . 2
COTTER PIN, HAIRPIN, 1/4”X 3/8” 2
Ref.
No.
Part
No.
06
100049
101029
651233
100059
100051
100883
101149
07
08
09
388
Description
Qty.
Req.
QUICK RELEASE PIN. . . . . . . . . . . 2
LANYARD . . . . . . . . . . . . . . . . . . . . 2
SCREW 1/4” . . . . . . . . . . . . . . . . . . 2
CLEVIS PIN, 1/4 DIA. . . . . . . . . . . . 4
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
(Attachment SN 11193 thru 13853)
4
3
9
2
2
5
6
1
7
10
8
Ref.
No.
01
02
03
04
05
06
07
Part
No.
101428
101427
101434
651233
101432
L520005
100059
100051
PRINTED IN U.S.A.
Description
Qty.
Req.
PWP FRAME . . . . . . . . . . . . . . . . . . 1
GUARD RAIL ASY. . . . . . . . . . . . . . 2
LATCH . . . . . . . . . . . . . . . . . . . . . . . 2
SCREW, 1/4” . . . . . . . . . . . . . . . . . . 6
STRIKER BOLT . . . . . . . . . . . . . . . . 2
NUT, 3/8-16 LOCK. . . . . . . . . . . . . . 2
CLEVIS PIN, 1/4 DIA. . . . . . . . . . . . 4
Ref.
No.
Part
No.
08
100049
101029
651233
100883
101149
09
10
389
Description
Qty.
Req.
QUICK RELEASE PIN. . . . . . . . . . . 2
LANYARD . . . . . . . . . . . . . . . . . . . . 2
SCREW 1/4” . . . . . . . . . . . . . . . . . . 2
907878/DP0208
Attachments
DL Series Dynalift
Carriage Forks
2” Shaft x 4
2” Long
2” Shaft x
48” Long
1
2
3
2” Shaft x
60” Long
4
6
5
2” Shaft x
72” Long
2-1/2” Sha
ft x 48”, 60
” & 72” Lo
ng
FRONT
10
7
11
8
12
9
13
907878/DP0208
390
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Carriage Forks
Ref.
No.
01a
02b
03a
04
05a
06
07
08
09
Part
No.
Description
Qty.
Req.
-- 2” FORK SHAFT DIAMETER -L71350
FORK, 42”X4”X2” (8,400 lbs.) . . . . . 2
L61001
FORK, 48”X2”X2” (4,200 lbs.) . . . . . 4
L61017
FORK, 48”X4”X2” (8,400 lbs.) . . . . . 2
L66406
FORK, 48”X4”X2-1/4” (12,000 lbs.). 2
L400929
FORK, 48”X5”X1-3/4” (8,500 lbs.). . 2
L47263
FORK, 48”X5”X2” (10,500 lbs.) . . . . 2
L47265
FORK, 60”X5”X2” (10,500 lbs.) . . . . 2
L60961
FORK, 60”X6”X2-1/4” (12,500 lbs.). 2
L68331
FORK, 72”X5”X2” (10,500 lbs.) . . . . 2
Ref.
No.
10cd
11d
12d
13d
a
b
c
d
Part
No.
Description
Qty.
Req.
-- 2-1/2” FORK SHAFT DIAMETER -210016
FORK, 48”X2”X2” (4,200 lbs.) . . . . . 6
L71159
FORK, 48”X6”X2” (12,640 lbs.) . . . . 2
L71160
FORK, 60”X6”X2” (12,640 lbs.) . . . . 2
L71161
FORK, 72”X6”X2” (12,640lbs.) . . . . 2
Not used on DL12
Requires 2 sets (4 forks).
Requires 3 sets (6 forks).
Used ONLY on DL12; requires a 2-1/2” bar
shaft.
Note: ratings are based on 2 forks and the load is 24” on
center. Except for item 2; where 4 forks are required, and
item 10; where 6 forks are required.
PRINTED IN U.S.A.
391
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Carriage
1
4
2
4
5
3
3
5
6
907878/DP0208
392
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynattach® Carriage
Ref.
No.
Part
No.
01
L99190
L99191
430171
430173
02
L65223
L64561
101625
101624
101240
101241
03
L400425
100369
PRINTED IN U.S.A.
Description
Qty.
Req.
CARRIAGE WELDMENT . . . . . . . . 1
48” (2” pin) . . . . . . . . . . . . . . . . . . . 1
66” (2” pin) . . . . . . . . . . . . . . . . . . . 1
Note e -- 48” (2-1/2” pin) . . . . . . . . . 1
Note e -- 66” (2-1/2” pin) . . . . . . . . . 1
FORK SHAFT BAR . . . . . . . . . . . . 1
(2”X51-1/2”) . . . . . . . . . . . . . . . . . . . 1
(2”X69-1/2”) . . . . . . . . . . . . . . . . . . . 1
Note c -- ( 2-1/2”X51-1/2”) . . . . . . . . 1
Note c -- (2-1/2”X69-1/2”) . . . . . . . . 1
Note d -- (2-1/2”X48-1/2”). . . . . . . . 1
Note d -- (2-1/2”X66-1/2”) . . . . . . . . 1
FORK SHAFT WASHER . . . . . . . . . 2
Note a
Note b
Ref.
No.
Part
No.
04
05
06
a
b
c
d
e
393
L510003
L50294
L520019
L500764
L50152
L50282
Description
Qty.
Req.
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
Note a -- 1/2”X2-3/4” BOLT . . . . . . 2
Note b -- 1/2”-13”X3-1/2” BOLT . . . 2
1/2”-13 NYLON INSERT NUT . . . . . 2
FORKSHAFT RETAINER . . . . . . . . 1
1/2” LOCK WASHER . . . . . . . . . . . 2
1/2”-13X1” BOLT . . . . . . . . . . . . . . 2
Used with 2” diameter Fork Shaft Bar
Used with 2-1/2” diameter Fork Shaft Bar
Used on carriages that do not use item 6 to retain
the Fork Shaft Bar.
Used on carriages that use item 6 to retain the Fork
Shaft Bar.
If your current carriage uses item 6 to retain the
Fork Shaft Bar, you will need to order the following
items when replacing the carriage: item 2, note c;
item 3; item 4 and item 5.
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Rotating Carriage
48” - Attachment SN 14031 and UP
48” Carriage
(shown)
1
7
2
6
3
4
5
8
8
23
14
13
26
9
25
12
9
11
7
10
24
23
22
21 20
15
17
9
16
19
18
907878/DP0208
394
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
103517
103518
103519
103520
L50982
L65181
L61307
L65273
L444004
L64294
L50273
L520005
L62026
L66017
L70655
L66017
L65180
L50145
PRINTED IN U.S.A.
Description
Qty.
Req.
CARRIAGE, ROTATING . . . . . . . . . 1
(48” Carriage) 2” dia. fork shaft
(48” Carriage) 2-1/2” dia. fork shaft
1/2”X4” BOLT. . . . . . . . . . . . . . . . . . 1
PIN, ROTATOR ROD END . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 4
QUICK COUPLER SET. . . . . . . . . . 1
ADAP -8ORM -8JICM STR . . . . . . . 2
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
3/8”X2-3/4” BOLT . . . . . . . . . . . . . . 3
3/8”-16 NYLON INSERT NUT . . . AR
LOCK COLLAR 1.5” OD . . . . . . . . . 2
ADAP -8ORM -8JICM 90 w/ORF. . . 2
ROTATE CYLINDER . . . . . . . . . . . . 1
PIN, ROTATOR BASE END . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . AR
Ref.
No.
Part
No.
16
17
18
19
20
21
22
23
24
101003
L50801
101999
L61709
L50147
L50261
L50718
L520019
L400425
100369
25
L510003
L50294
26
L65223
L64561
101625
101624
395
Description
Qty.
Req.
ROTATOR PIN. . . . . . . . . . . . . . . . . 1
3/8”X4” BOLT. . . . . . . . . . . . . . . . . . 1
ROTATOR PLATE WELDMENT . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 3
3/8” LOCK WASHER . . . . . . . . . . . . 6
3/8”X1-1/2” BOLT . . . . . . . . . . . . . . 6
2-1/2”-12 CASTELL NUT. . . . . . . . . 1
1/2”-13 NYLON INSERT NUT . . . . . 4
2” ID
2-1/2” ID
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
1/2”X2-3/4” BOLT (2” dia. shaft)
1/2”X2-3/4” BOLT (2-1/2” dia.shaft)
FORK SHAFT BAR . . . . . . . . . . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
48” - Attachment SN 14030 and before
9
11 12
8
13
14
10
15
7
19
16
1
6
13
17
7
5
3
18
2
4
21
20
6
1
25
26
27
22
23
15
24
28
907878/DP0208
396
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Ref.
No.
Part
No.
01
02
L520019
L400425
03
L510003
04
L65223
L64561
05
06
07
08
09c
10
11
12
13
14
15
16
L99223
L99222
L66017
L64294
L444004
NSS
L50982
L61307
L62026
L50273
L65181
L520005
L61317
L70655
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
1/2”-13 NYLON INSERT NUT . . . . . 4
(2” dia. fork shaft)
1/2”X2-3/4” BOLT . . . . . . . . . . . . . . 2
(2” dia. fork shaft)
FORK SHAFT BAR . . . . . . . . . . . . . 1
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
ADAP -8ORM -8JICM STR . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
1/2”-13X4” BOLT . . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . . 4
LOCK COLLAR 1.5” OD . . . . . . . . . 2
3/8”X2-3/4” BOLT . . . . . . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 3
ROTATE CYLINDER . . . . . . . . . . . . 1
Note a
Note b
17
18
19c
20
21
L50896
L65180
NSS
NSS
L65167
22
23
24
25
26
27
28
L61709
L61287
L50801
L50718
L50147
L50261
L810005
a
b
c
Attachment thru SN 5483
Attachment SN 5484 Thru 14289
Order PN L65273 Coupler Set
397
Description
Qty.
Req.
1/2”-13X4-1/2” BOLT . . . . . . . . . . . . 1
COUPLER, FEMALE. . . . . . . . . . . . 1
ROTATOR PIN. . . . . . . . . . . . . . . . . 1
(Includes Item 20)
SLIDE PAD . . . . . . . . . . . . . . . . . . . 3
4”ODX2.5”ID WASHER . . . . . . . . . . 1
3/8”X4” BOLT. . . . . . . . . . . . . . . . . . 1
2-1/2”-12 CASTELL NUT. . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . . 6
3/8”X1-1/2” BOLT . . . . . . . . . . . . . . 6
PIVOT BEARING (not shown). . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Swing Carriage
8
13
14
15
17
16
7
7
9
6
5
25
24
12
10
18
11
18
23 22 21
30
26
3
1
19
20
10
27
4
28
29
2
31
32
35
33
34
907878/DP0208
398
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynattach® Swing Carriage
Ref.
No.
Part
No.
01
02
03
04
05
06a
07
08
09a
10
11
12
13
14
15
16
17
18
19
20
21
L520019
L400425
L510003
L64561
L500216
NSS
L63143
L66958
NSS
L63984
L50895
L50835
L520003
L50452
L63995
L63593
L63970
L445004
L63983
L446049
L445003
PRINTED IN U.S.A.
Description
Qty.
Req.
1/2”-13 NYLON INSERT NUT . . . . . 2
1/2”X2-3/4” BOLT . . . . . . . . . . . . . . 2
FORK SHAFT BAR (66” Carriage) . 1
66” CARRIAGE, SWING . . . . . . . . . 1
COUPLER, FEMALE. . . . . . . . . . . . 1
ADAP -8ORM -6JICM STR w/ORF 2
HOSE -6 A6/A6 89” . . . . . . . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
HOSE -4 DS6/A6 22” . . . . . . . . . . . 2
5/16”X3” BOLT. . . . . . . . . . . . . . . . . 1
5/16”X2” BOLT. . . . . . . . . . . . . . . . . 1
1/4” NYLON INSERT NUT . . . . . . . 4
1/4”X2-1/4” BOLT . . . . . . . . . . . . . . 4
PIN, SWING CYLINDER . . . . . . . . . 4
BUSHING . . . . . . . . . . . . . . . . . . . . 4
SWING CYLINDER . . . . . . . . . . . . . 2
ADAP -6ORM -6JICM 45. . . . . . . . . 4
HOSE -4 A6/A6 36” . . . . . . . . . . . . . 2
ADAP -6JICFS -6JICM TEE . . . . . . 2
ADAP -6ORM -6JICM 90. . . . . . . . . 2
Ref.
No.
Part
No.
22
23
24
25
26
27
28
29
30
31
32
33
34
35
L50561
L50143
L63715
L63716
L71651
L63233
L50056
NSS
L63994
L70719
L520005
L50273
L63951
L63468
a
399
Description
Qty.
Req.
5/16”-18X1-3/4” BOLT . . . . . . . . . . . 2
5/16” LOCK WASHER . . . . . . . . . . . 2
TWIN CUSH. TOP PLATE. . . . . . . . 1
VALVE, DUAL PO . . . . . . . . . . . . . . 1
HOSE CUSH. TOP PLATE . . . . . . . 1
5/16” FLARE NUT . . . . . . . . . . . . . . 2
NAME PLATE . . . . . . . . . . . . . . . . . 1
PIN, CARRIAGE PIVOT . . . . . . . . . 2
SWING PIVOT WELDMENT . . . . . . 1
3/8”-16 NYLON INSERT NUT . . . . . 2
3/8”-16X2-3/4” BOLT . . . . . . . . . . . . 2
THRUST WASHER . . . . . . . . . . . . . 6
BUSHING, CARRIAGE PIVOT . . . . 2
(Not shown)
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Log/Pipe Carriage
12
13
14
11
3
10
4
7
5
6
2
8
1
15
9
11
16
23
24
26
22
17
21
25
18
3
20
19
27
907878/DP0208
400
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynattach® Log/Pipe Carriage
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
Part
No.
L67347
L50371
L520005
L67246
L61866
L10057
L520003
L66811
L63593
L50452
L445003
L67495
L67598
L67599
Description
Qty.
Req.
Ref.
No.
Part
No.
LOG GRAPPLE WELDMENT . . . . . 1
3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 6
LOG GRAPPLE PIVOT PIN . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
1/4-28 GREASE ZERK 90 DEG . . . 2
1/4” NYLON INSERT NUT . . . . . . . 2
GRAPPLE CYLINDER PIN . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
1/4X2-1/4” BOLT . . . . . . . . . . . . . . . 2
CYLINDER COVER. . . . . . . . . . . . . 1
HOSE -4 A6/A6 32” . . . . . . . . . . . . . 1
HOSE -4 A6/A6 20” . . . . . . . . . . . . . 1
15
16
17
18
19a
20a
21
22
23
24
25
26
27
L67248
L50561
L66831
L63143
NSS
NSS
L50143
L444002
L65689
L500220
L50275
L66809
L66805
100547
a
PRINTED IN U.S.A.
401
Description
Qty.
Req.
LOG GRAPPLE CYLINDER . . . . . . 1
5/16”-18X1-3/4” BOLT . . . . . . . . . . . 2
HOSE -6 A6/A6 52” . . . . . . . . . . . . . 2
ADAP -8ORM -6JICM w/ORF . . . . . 2
COUPLER, FEMALE. . . . . . . . . . . . 1
COUPLER, MALE . . . . . . . . . . . . . . 1
5/16” LOCKWASHER . . . . . . . . . . . 2
ADAP -6ORM -6JICM . . . . . . . . . . . 2
VALVE, DOUBLE PORT CHECK . . 1
LOG CARRIAGE WELDMENT . . . . 1
3/8”-16X3” BOLT . . . . . . . . . . . . . . . 4
LOG FORK SHAFT . . . . . . . . . . . . . 2
LOG FORK WELDMENT . . . . . . . . 2
2”x5”x48”
2”x5”x60”
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Fork-Shift Carriage
1
19
20
18
14
15
13
2
11
15
9
12
16
17
9
10
8
7
6
5
2
3
4
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13b
L500213
L50519
L400425
L50333
L66919
L66931
L50875
Note a
L63715
L50242
L63716
L520004
NSS
907878/DP0208
Description
Qty.
Req.
Ref.
No.
Part
No.
FORK SHIFT CARRIAGE . . . . . . . . 1
3/4”-10 NYLON INSERT NUT . . . . . 3
3/4”-10X3” BOLT . . . . . . . . . . . . . . 1
FORK SHAFT, 50” . . . . . . . . . . . . . . 1
FORK SLIDE PLATE . . . . . . . . . . . . 2
3/4”-10X1-1/2” BOLT . . . . . . . . . . . . 1
FORK SLIDE COUPLER. . . . . . . . . 1
5/16”-18X2-1/4” BOLT . . . . . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
14b
15
16
17
18
19
20
NSS
L66918
L68337
L50562
L63143
L66950
L66949
a
For 4” wide forks use PN L66921.
For 5” wide forks use PN L66948.
b
402
Description
Qty.
Req.
COUPLER, FEMALE. . . . . . . . . . . . 1
CYLINDER MOUNT . . . . . . . . . . . . 2
FORK SHIFT CYLINDER . . . . . . . . 1
3/4”-10X4” BOLT . . . . . . . . . . . . . . . 2
ADAP -8ORM -6JICM W/.06 ORF . 2
HOSE -6 A6/A6 59” . . . . . . . . . . . . . 1
HOSE -6 A6/A6 56” . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynattach® Bucket
1
2
Ref.
No.
01
02
Part
No.
L500374
L68831
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
1.3 CU. YD. BUCKET WELDMNT . 1
CUTTING EDGE, 98”x6”x3/4” . . . . . 1
(weld on)
403
907878/DP0208
Attachments
DL Series Dynalift
Dynattach® Truss Boom
5’ JIB BOOM
1
1
12’ AND 15’
TRUSS BOOM
24
25
15
16
18 17
7
6
23
26
5
22
14
21
13
20
19
10
3
2
12
8
11
4
9
907878/DP0208
404
8
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynattach® Truss Boom
Ref.
No.
01
Part
No.
05
06e
07e
08
09
10a
11
12
13
14
15
16
17
18
19b
L500218
L99236
L99235
L64294
L64660
L50841
L520003
L444004
NSS
NSS
L445002
L82358
100963
L50286
L520019
L444008
L400398
L50815
100076
L520004
L65338
L71266
19c
L66946
20
21
22
L50371
L50147
L60451
02
03
04
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
5’ TRUSS WELDMENT . . . . . . . . . . 1
12’ TRUSS WELDMENT . . . . . . . . . 1
15’ TRUSS WELDMENT . . . . . . . . . 1
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2
ADAP -8ORM -8JICM STR . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
COUPLER, FEMALE. . . . . . . . . . . . 1
RELIEF VALVE . . . . . . . . . . . . . . . . 1
HYDRAULIC WINCH. . . . . . . . . . . . 1
1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 6
ADAP -10ORM -8JICM . . . . . . . . . . 2
HOSE -6 A8/A8 18.5” . . . . . . . . . . . 2
5/16”X2-1/2” BOLT . . . . . . . . . . . . . 2
PIN, TRUSS WINCH . . . . . . . . . . . . 1
WINCH SHEAVE . . . . . . . . . . . . . . . 1
3/8”X100’ WINCH CABLE . . . . . . . . 1
(Includes hook and swivel)
3/8”X60’ WINCH CABLE . . . . . . . . . 1
3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2
3/8” LOCK WASHER . . . . . . . . . . . . 2
WINCH BALL. . . . . . . . . . . . . . . . . . 1
23
24
25
26d
L61411
L50380
L50152
L446017
PINTLE HOOK . . . . . . . . . . . . . . . . 1
1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 4
1/2” LOCK WASHER . . . . . . . . . . . . 4
ADAP -8JICFS -8JICM 90 . . . . . . . . 2
00
L500223
-- ITEMS NOT SHOWN-ADAPTER PLATE . . . . . . . . . . . . . . 1
(Used with auger.)
a
Used on all 12’ and 15’ Truss Booms equipped with
a winch, and on 5’ Jib Booms after attachment
serial number 11182. The winch on 5’ Jib
Booms before attachment serial number 11183
has been discontinued. You must purchase a
Jib Boom and a winch.
b
Used with 12’ and 15’ Truss Booms with winch.
c
Used with 5’ Jib Booms with winch.
d
Not used on some attachments.
e
405
Description
Qty.
Req.
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Carriage
1
4
3
2
4
3
5
5
6
907878/DP0208
406
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynacarrier ® Carriage
Ref.
No.
Part
No.
01
L500196
L500197
430170
430172
02
L65223
L64561
101625
101624
101240
101241
03
04
L400425
100369
L520019
PRINTED IN U.S.A.
Description
Qty.
Req.
CARRIAGE WELDMENT . . . . . . . . 1
48” (2” pin) . . . . . . . . . . . . . . . . . . . 1
66” (2” pin) . . . . . . . . . . . . . . . . . . . 1
Note e -- 48” (2-1/2” pin) . . . . . . . . . 1
Note e -- 66” (2-1/2” pin) . . . . . . . . . 1
FORK SHAFT BAR . . . . . . . . . . . . 1
(2”X51-1/2”) . . . . . . . . . . . . . . . . . . . 1
(2”X69-1/2”) . . . . . . . . . . . . . . . . . . . 1
Note c -- ( 2-1/2”X51-1/2”) . . . . . . . . 1
Note c -- (2-1/2”X69-1/2”) . . . . . . . . 1
Note d -- (2-1/2”X48-1/2”). . . . . . . . 1
Note d -- (2-1/2”X66-1/2”) . . . . . . . . 1
Note a
Note b
1/2”-13 NYLON INSERT NUT . . . . . 2
Ref.
No.
Part
No.
05
Description
Qty.
Req.
L510003
L50294
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
Note a -- 1/2”X2-3/4” BOLT . . . . . . 2
Note b -- 1/2”-13”X3-1/2” BOLT . . . 2
06
L500764
L50152
L50282
FORKSHAFT RETAINER . . . . . . . . 1
1/2” LOCK WASHER . . . . . . . . . . . 2
1/2”-13X1” BOLT . . . . . . . . . . . . . . 2
a
b
c
Used with 2” diameter Fork Shaft Bar
Used with 2-1/2” diameter Fork Shaft Bar
Used on carriages that do not use item 6 to retain
the Fork Shaft Bar.
Used on carriages that use item 6 to retain the Fork
Shaft Bar.
If your current carriage uses item 6 to retain the
Fork Shaft Bar, you will need to order the following
items when replacing the carriage: item 2, note c;
item 3; item 4 and item 5.
d
e
407
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Rotating Carriage
48” Carriage
(shown)
1
7
2
6
3
4
5
8
23
14
8
13
26
25
9
12
9
7
10
24
23
22
21
20
11
19
15
9
18
16
17
907878/DP0208
408
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
103517
103518
103519
103520
L50982
L65181
L61307
L65273
L444004
L64294
L50273
L520005
L62026
L66017
L70655
L66017
L65180
L50145
PRINTED IN U.S.A.
Description
Qty.
Req.
1/2”X4” BOLT. . . . . . . . . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 4
QUICK COUPLER SET. . . . . . . . . . 1
ADAP -8ORM -8JICM STR . . . . . . . 2
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
3/8”X2-3/4” BOLT . . . . . . . . . . . . . . 3
3/8”-16 NYLON INSERT NUT . . . AR
LOCK COLLAR 1.5” OD . . . . . . . . . 2
ROTATE CYLINDER . . . . . . . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . AR
Ref.
No.
Part
No.
16
17
18
19
20
21
22
23
24
101003
L50801
101002
L61709
L50147
L50261
L50718
L520019
L400425
100369
25
L510003
L50294
26
L65223
L64561
101625
101624
409
Description
Qty.
Req.
ROTATOR PIN. . . . . . . . . . . . . . . . . 1
3/8”X4” BOLT. . . . . . . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 3
3/8” LOCK WASHER . . . . . . . . . . . . 6
3/8”X1-1/2” BOLT . . . . . . . . . . . . . . 6
2-1/2”-12 CASTELL NUT. . . . . . . . . 1
1/2”-13 NYLON INSERT NUT . . . . . 4
2” ID
2-1/2” ID
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 2
1/2”X2-3/4” BOLT (2” dia. shaft)
1/2”X2-3/4” BOLT (2-1/2” dia.shaft)
FORK SHAFT BAR . . . . . . . . . . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
48” Carriage
(shown)
2
9
3
8
4
7
1
10
12
5
6
11
13
9
14
15
16
17
18
14
19
20
27
26
21
25
24
23
22
6
907878/DP0208
410
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Ref.
No.
01
02
03a
04a
05
06
07
08
09
10
11
12
13
14
Part
No.
L500230
L500231
L64294
NSS
NSS
L444004
L520019
L65181
L50896
L66017
L70655
L61307
L50273
L62026
L520005
PRINTED IN U.S.A.
Description
Qty.
Req.
48” CARRIAGE, ROTATING . . . . . . 1
66” CARRIAGE, ROTATING . . . . . . 1
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
COUPLER, FEMALE. . . . . . . . . . . . 1
ADAP -8ORM -8JICM STR . . . . . . . 2
1/2”-13 NYLON INSERT NUT . . . . . 3
1/2”-13X4-1/2” BOLT . . . . . . . . . . . . 1
ADAP -8ORM -8JICM 90 W/ORF.. . 2
ROTATE CYLINDER . . . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . . 4
3/8”X2-3/4” BOLT . . . . . . . . . . . . . . 3
LOCK COLLAR 1.5” OD . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 3
Ref.
No.
Part
No.
15
16
L65180
L70862
17
18
19
20
21
22
23
24
25
26
27
NSS
L810005
L61709
L510003
L400425
L65223
L64561
L50147
L50261
L50801
L61287
L50718
a
411
Description
Qty.
Req.
(Includes Item 17)
ROTATOR PIN. . . . . . . . . . . . . . . . . 1
PIVOT BEARING. . . . . . . . . . . . . . . 1
SLIDE PAD . . . . . . . . . . . . . . . . . . . 3
1/2”X2-3/4” BOLT . . . . . . . . . . . . . . 2
3/8” LOCK WASHER . . . . . . . . . . . . 6
3/8”X1-1/2” BOLT . . . . . . . . . . . . . . 6
3/8”X4” BOLT. . . . . . . . . . . . . . . . . . 1
4”ODX2.5”ID WASHER . . . . . . . . . . 1
2-1/2”-12 CASTELL NUT. . . . . . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Log/Pipe Carriage
12
13
14
11
3
10
4
7
5
6
2
8
1
15
9
11
16
23
24
26
22
17
21
25
18
3
20
19
27
907878/DP0208
412
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynacarrier ® Log/Pipe Carriage
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19c
20c
L67347
L50371
L520005
L67246
L61866
L10057
L520003
L66811
L63593
L50452
L445003
L67495
L67598
L67599
L67248
L50561
L66831
L63143
NSS
NSS
PRINTED IN U.S.A.
Description
Qty.
Req.
LOG GRAPPLE WELDMENT . . . . . 1
3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2
3/8”-16 NYLON INSERT NUT . . . . . 6
LOG GRAPPLE PIVOT PIN . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
1/4-28 GREASE ZERK 90 DEG . . . 2
1/4” NYLON INSERT NUT . . . . . . . 2
GRAPPLE CYLINDER PIN . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . . 2
1/4X2-1/4” BOLT . . . . . . . . . . . . . . . 2
CYLINDER COVER. . . . . . . . . . . . . 1
HOSE -4 A6/A6 32” . . . . . . . . . . . . . 1
HOSE -4 A6/A6 20” . . . . . . . . . . . . . 1
LOG GRAPPLE CYLINDER . . . . . . 1
5/16”-18X1-3/4” BOLT . . . . . . . . . . . 2
HOSE -6 A6/A6 52” . . . . . . . . . . . . . 2
ADAP -8ORM -6JICM w/ORF . . . . . 2
COUPLER, FEMALE. . . . . . . . . . . . 1
COUPLER, MALE . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
21
22
23
24
L50143
L444002
L65689
103528
L500210
25
L50275
L50273
26
L66809
L67267
27
100547
L66805
L67239
a
b
c
413
Description
Qty.
Req.
5/16” LOCKWASHER . . . . . . . . . . . 2
ADAP -6ORM -6JICM . . . . . . . . . . . 2
VALVE, DOUBLE PORT CHECK . . 1
LOG CARRIAGE WELDMENT . . . . 1
Note a
Note b
BOLT . . . . . . . . . . . . . . . . . . . . . . . . 4
Note a (3/8”-16X3”)
Note b (3/8”-16X2-3/4”)
LOG FORK SHAFT . . . . . . . . . . . . . 2
Note a
Note b
LOG FORK WELDMENT . . . . . . . . 2
Note a (2”X5”x60”)
(2”x5”x48”)
Note b (2”X4”X42”)
Attachment SN 6311 and up
Attachment SN 6310 and before
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Truss Boom
5’ JIB BOOM
1
1
12’ AND 15’
TRUSS BOOM
24
25
7
6
26
5
15
14
16
18 17
13
23
22
10
3
21
20
2
19
12
8
11
4
9
907878/DP0208
414
8
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynacarrier ® Truss Boom
Ref.
No.
01
01
01
02
03
04
Part
No.
05
06e
07e
08
09
10a
11
12
13
14
15
16
17
18
19b
L500212
L99238
L500350
L64294
L64660
L50841
L520003
L444004
NSS
NSS
L445002
L82358
100963
L50286
L520019
L444008
L400398
L50815
100076
L520004
L65338
L71266
19c
L66946
20
L50371
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
5’ JIB TRUSS WELDMENT. . . . . . . 1
12’ TRUSS WELDMENT . . . . . . . . . 1
15’ TRUSS WELDMENT . . . . . . . . . 1
HOSE -8 A8/A8 53” . . . . . . . . . . . . . 2
1/4-20”X2” BOLT . . . . . . . . . . . . . . . 2
ADAP -8ORM -8JICM STR . . . . . . . 2
COUPLER, MALE . . . . . . . . . . . . . . 1
COUPLER, FEMALE. . . . . . . . . . . . 1
RELIEF VALVE . . . . . . . . . . . . . . . . 1
HYDRAULIC WINCH. . . . . . . . . . . . 1
1/2”-13X1-3/4” GR 8 BOLT . . . . . . . 6
ADAP -10ORM -8JICM . . . . . . . . . . 2
HOSE -6 A8/A8 18.5” . . . . . . . . . . . 2
5/16”X2-1/2” BOLT . . . . . . . . . . . . . 2
PIN, TRUSS WINCH . . . . . . . . . . . . 1
WINCH SHEAVE . . . . . . . . . . . . . . . 1
3/8”X100’ WINCH CABLE . . . . . . . . 1
3/8”X60’ WINCH CABLE . . . . . . . . . 1
3/8”X2-1/2” BOLT . . . . . . . . . . . . . . 2
21
22
23
24
25
26d
L50147
L60451
L61411
L50380
L50152
L446017
3/8” LOCK WASHER . . . . . . . . . . . . 2
WINCH BALL. . . . . . . . . . . . . . . . . . 1
PINTLE HOOK . . . . . . . . . . . . . . . . 1
1/2”-20X1-1/4” GR 8 BOLT . . . . . . . 4
1/2” LOCK WASHER . . . . . . . . . . . . 4
ADAP -8JICFS -8JICM 90 . . . . . . . . 2
00
L500221
-- ITEMS NOT SHOWN-ADAPTER PLATE . . . . . . . . . . . . . . 1
(Used with auger.)
a
Used on all 12’ and 15’ Truss Booms equipped with
a winch, and on 5’ Jib Booms after attachment
serial number 11182. The winch on 5’ Jib
Booms before attachment serial number 11183
has been discontinued. You must purchase a
Jib Boom and a winch.
b
Used with 12’ and 15’ Truss Booms with winch.
c
Used with 5’ Jib Booms with winch.
d
Not used on some attachments.
e
415
Description
Qty.
Req.
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Bucket / 1.3-Cubic-Yard
1
2
3
4
Ref.
No.
01
02
Part
No.
L500189
L50519
907878/DP0208
Description
Qty.
Req.
BUCKET WELDMENT 1.3 CU YD . 1
Ref.
No.
Part
No.
03
04
L69167
L50284
416
Description
Qty.
Req.
REVERSIBLE CUTTING EDGE . . . 1
3/4”-10X2-1/2” PLOW BOLT . . . . . 16
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynacarrier ® Bucket / 2-Cubic-Yard
1
2
3
4
Ref.
No.
01ab
02
03
04
Part
No.
L50519
L69167
L50284
PRINTED IN U.S.A.
Description
Qty.
Req.
BUCKET WELDMENT 2 CU YD . . . 1
REVERSIBLE CUTTING EDGE . . . 1
3/4”-10X2-1/2” PLOW BOLT . . . . . 16
Ref.
No.
a
Part
No.
Description
Qty.
Req.
b
Order Stock Number 820005, which includes all
items shown.
Use L71640 weldment for open back scrap bucket
00
00
00
00
Optional for open back scrap bucket
L67624
BOLT ON SIDE PLATE KIT
L67620
BOLT ON SIDE PLATE . . . . . . . . . 2
L50286
1/2”-13X1-3/4” BOLT . . . . . . . . . . 10
L520019
1/2”-13 NYLON INSERT NUT . . . 10
417
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Dual Top Clamp Group
28 32
31
24
23
25
29
32
30
27 28
26
22
29
30
33
26
34
21
20
1
21
23
19
2
35
36
37
38
40
39
22
3
6
24
4
5
4
7
5
6
8
10
9
18
17
12
11
13
14
15
16
907878/DP0208
418
PRINTED IN U.S.A.
DL Series Dynalift
Attachments
Dynacarrier ® Dual Top Clamp Group
Ref.
No.
Part
No.
01a
02a
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
NSS
NSS
L67514
L520019
L41770
L50288
L71708
L520004
L67510
L67609
L67608
L67611
L67610
L67577
L67576
L67494
L67749
L50836
L50403
L67740
PRINTED IN U.S.A.
Description
Qty.
Req.
FEMALE FLAT COUPLER . . . . . . . 1
MALE FLAT COUPLER . . . . . . . . . . 1
HOSE DM6/B8 57” . . . . . . . . . . . . . 1
VINYL COVERED CLAMP . . . . . . . 4
1/2-13X2” BOLT. . . . . . . . . . . . . . . . 4
CHECK VALVE BRACKET . . . . . . . 1
ADAP BULKHEAD -6JICM TEE. . . 2
HOSE A6/A6 33” . . . . . . . . . . . . . . . 1
HOSE A6/A6 41” . . . . . . . . . . . . . . . 1
HOSE A6/H6 30” . . . . . . . . . . . . . . . 1
HOSE A6/H6 40” . . . . . . . . . . . . . . . 1
TUBE, BULKHEAD OUTSIDE CYL 1
TUBE, BULKHEAD INSIDE CYL . . 1
CYLINDER COVER LEFT HAND . . 1
GRAPPLE ENCLOSURE . . . . . . . . 2
3/8-16X1-3/4” BOLT . . . . . . . . . . . . 4
3/8-16X1-1/4” BOLT . . . . . . . . . . . 12
GRAPPLE WELDMENT . . . . . . . . . 2
Ref.
No.
Part
No.
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
L10465
L50371
L67491
L520005
L48806
L520003
L67258
L50452
L63593
L10057
L67489
L445003
L67495
L67248
L69903
L445004
L71651
L50561
L444002
L67802
a
419
Description
Qty.
Req.
ZERK, 1/4-28 STRAIGHT . . . . . . . . 4
3/8-16X2-1/2” BOLT . . . . . . . . . . . . 4
PIN, GRAPPLE PIVOT . . . . . . . . . . 4
BUSHING, 1-1/2” ODX1-1/4” ID . . . 4
PIN, GRAPPLE CYL ROD END . . . 2
1/4-20X2-1/4” BOLT . . . . . . . . . . . . 4
BUSHING, 1.01X1.25X1.5. . . . . . . . 4
ZERK, 1/4-28 90 DEGREE . . . . . . 4
PIN, GRAPPLE CYL BUTT END. . . 2
CYLINDER COVER RIGHT HND . . 1
CYLINDER, GRAPPLE . . . . . . . . . . 2
HOSE A6/DS6 17” . . . . . . . . . . . . . . 2
DUAL PO CHECK VALVE . . . . . . . . 1
5/16-18X1-3/4” BOLT . . . . . . . . . . . 2
ADAP -6ORM -6JICM STRAIGHT . 2
HOSE DM6/B8 55” . . . . . . . . . . . . . 1
907878/DP0208
Attachments
DL Series Dynalift
Dynacarrier ® Bucket / 3-Cubic-Yard
1
7
6
5
4
Ref.
No.
01
04
05
Part
No.
L500660
L50519
100341
907878/DP0208
Description
Qty.
Req.
BUCKET WELDMENT 3 CU YD . . . 1
CUTTING EDGE - 101-3/8” LONG . 1
Ref.
No.
Part
No.
06
07
L50284
100323
420
Description
Qty.
Req.
3/4”-10X2-1/2” PLOW BOLT . . . . . 17
WELD ON EDGE W / HOLES. . . . . 1
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
056859
067847
067847
067847
076099
078849
080313
080319
088296
089069
089069
089070
089070
100003
100003
100006
100007
100008
100008
100044
100047
100049
100049
100051
100051
100051
100056
100057
100058
100059
100059
100071
100076
100076
100091
100102
100118
100118
100118
100118
100135
100247
100249
100252
100252
100252
100255
100255
100255
100259
100260
100263
100264
100323
100330
100332
100341
15
83
95
261
386
9
381
383
21
49
51
49
51
139
163
139
139
139
163
388
388
388
389
388
388
389
388
388
388
388
389
73
405
415
61
81
207
209
243
245
73
207
243
163
299
301
163
299
301
163
163
115
115
420
163
163
420
10
43
14
09
08
00
05
02
00
09
33
09
33
04
04
06
06
04
04
01
02
06
08
05
07
07
05
04
03
07
07
17
16
16
12
18
03
09
03
04
01
01
01
09
25
18
10
18
12
06
06
08
08
07
13
13
05
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
100369
100369
100369
100369
100403
100404
100501
100547
100547
100751
100751
100883
100883
100883
100883
100963
100963
101002
101003
101003
101028
101029
101029
101053
101055
101149
101149
101149
101149
101158
101198
101199
101212
101212
101212
101212
101226
101240
101240
101241
101241
101247
101250
101278
101291
101308
101308
101317
101317
101319
101319
101320
101320
101349
101349
101351
101351
393
395
407
409
115
115
61
401
413
63
93
386
387
388
389
405
415
409
395
409
233
388
389
209
245
386
387
388
389
25
77
77
203
203
233
233
63
393
407
393
407
85
93
51
71
165
385
251
261
265
265
259
265
83
101
207
209
03
24
03
24
01
01
12
27
27
14
29
06
06
08
09
10
10
18
16
16
12
06
08
01
01
00
00
09
10
16
03
00
15
15
15
15
12
02
02
02
02
03
06
32
13
43
01
03
11
04
05
17
10
08
10
02
10
Part
No.
Page
No.
Ref.
No.
101351
101351
101356
101364
101378
101378
101378
101383
101383
101397
101418
101421
101422
101427
101428
101432
101434
101436
101439
101443
101453
101457
101487
101488
101490
101491
101492
101493
101493
101494
101495
101495
101508
101508
101523
101524
101528
101550
101624
101624
101624
101624
101625
101625
101625
101625
101650
101650
101667
101668
101682
101687
101688
101689
101692
101692
101704
243
245
21
85
51
55
59
261
261
83
21
83
83
389
389
389
389
83
297
21
83
85
21
83
51
51
51
51
73
51
33
95
55
59
101
51
51
51
393
395
407
409
393
395
407
409
55
59
21
61
103
63
63
75
261
265
21
02
03
13
19
35
00
27
03
08
41
01
36
39
02
01
05
03
40
16
00
47
11
04
09
09
08
05
10
19
13
19
22
00
28
12
12
14
06
02
26
02
26
02
26
02
26
32
22
07
12
05
05
06
07
01
06
22
421
Part
No.
Page
No.
101709
101709
101710
101711
101713
101714
101716
101717
101717
101718
101719
101720
101721
101723
101725
101726
101727
101728
101729
101730
101731
101737
101738
101739
101740
101741
101742
101743
101743
101744
101745
101746
101747
101748
101749
101750
101750
101751
101752
101753
101754
101755
101756
101757
101758
101759
101761
101762
101763
101764
101767
101772
101773
101774
101774
101790
101792
43
47
47
21
21
21
21
29
33
33
43
23
23
33
27
27
39
39
39
39
39
47
47
47
47
47
47
43
47
47
47
47
47
47
47
43
47
47
47
43
43
43
43
43
43
43
39
47
43
27
21
23
23
21
23
39
47
Ref.
No.
11
07
14
19
23
22
00
11
10
05
16
20
19
01
03
01
05
12
13
14
15
04
08
09
10
11
12
13
13
15
16
17
18
19
22
18
23
24
25
04
10
12
14
15
19
21
00
00
00
00
18
18
17
14
18
11
15
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
101793
101794
101814
101818
101825
101825
101827
101828
101835
101836
101840
101840
101841
101841
101843
101843
101848
101848
101849
101849
101869
101870
101881
101884
101902
101906
101907
101909
101909
101910
101912
101914
101926
101960
101961
101962
101963
101965
101966
101967
101972
101974
101992
101999
102002
102031
102064
102065
102066
102072
102073
102110
102110
102111
102168
102169
102170
47
47
251
93
55
59
95
95
331
331
55
59
55
59
55
59
55
59
55
59
93
93
267
67
21
47
43
43
47
43
47
23
101
85
85
85
85
83
83
83
21
21
331
395
83
95
95
95
95
331
331
115
331
331
63
63
63
26
28
14
06
12
12
05
16
10
09
25
19
27
21
26
20
36
26
35
25
23
16
01
01
10
00
00
18
23
19
22
18
05
03
04
04
03
00
00
27
01
01
02
18
26
07
02
23
20
15
16
04
14
20
28
26
27
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
102171
102173
102174
102258
102262
102278
102279
102280
102289
102291
102292
102322
102322
102323
102324
102408
102655
102675
102676
102677
102962
102963
103008
103008
103009
103009
103010
103010
103045
103046
103047
103048
103049
103050
103051
103052
103052
103053
103053
103054
103056
103057
103058
103061
103063
103065
103066
103067
103068
103086
103087
103101
103104
103159
103194
103413
103413
63
9
9
331
95
95
331
331
331
95
95
53
57
165
165
76
77
77
77
77
25
25
143
155
143
155
53
57
341
341
341
341
341
341
341
341
344
341
344
341
341
341
341
341
341
341
341
341
341
344
344
25
25
25
271
279
283
23
01
04
19
00
01
01
08
15
13
17
03
03
18
04
01
00
02
01
04
01
02
01
01
17
19
11
11
12
08
14
11
17
16
18
09
04
15
02
01
04
02
03
05
01
04
02
00
07
03
05
19
18
09
07
07
14
Part
No.
Page
No.
Ref.
No.
103413
103413
103414
103425
103425
103425
103441
103475
103476
103479
103482
103483
103484
103485
103486
103487
103505
103505
103505
103506
103506
103506
103508
103509
103510
103511
103512
103513
103514
103517
103517
103518
103518
103519
103519
103520
103520
103528
103626
103862
103878
103878
103899
103900
103901
103902
103905
103905
103906
103907
103908
103909
103910
103910
103911
103911
103912
287
349
79
279
283
287
9
79
79
79
79
167
167
167
167
167
279
283
287
279
283
287
349
349
349
349
349
349
349
395
409
395
409
395
409
395
409
413
93
93
291
352
271
271
271
271
386
387
386
386
386
386
386
387
386
387
33
06
00
00
09
09
10
05
05
06
01
02
03
03
03
04
19
02
02
02
01
01
01
01
03
02
01
03
00
00
01
01
01
01
01
01
01
01
24
07
00
01
00
06
17
15
14
01
01
02
03
04
05
00
00
00
00
19
422
Part
No.
Page
No.
Ref.
No.
104016
104024
104065
104078
104223
104223
104304
104304
104320
104340
104341
104675
104867
104868
104869
104952
104963
105082
105082
105159
105159
105161
105164
105165
105166
105166
105167
105167
105236
105238
105239
105261
105270
105271
105502
105556
105603
105604
105605
105606
105845
105851
131799
131940
137497
137502
137502
138563
210016
210018
430170
430171
430172
430173
520013
650027
650484
353
93
75
75
355
357
355
357
341
93
93
79
115
115
137
25
79
135
137
271
341
271
271
344
247
271
271
331
65
385
385
385
385
385
71
341
387
387
387
387
386
137
81
81
25
55
59
55
391
338
407
393
407
393
113
95
331
02
00
07
06
09
08
12
11
13
33
34
07
01
17
37
00
00
01
00
01
00
21
16
01
01
24
12
19
23
01
00
09
08
08
13
06
02
03
04
05
07
45
25
22
10
34
24
06
10
01
01
01
01
01
03
09
11
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
650486
650488
650490
650490
650490
650542
650697
650835
651233
651233
651233
651574
651599
651719
653005
654002
654022
654022
654022
654022
654022
654022
654026
654028
654049
654049
654049
656016
656052
L10057
L10057
L10057
L10057
L10057
L10057
L10057
L10057
L10057
L10057
L10057
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
L10465
331
261
83
95
261
53
23
83
388
389
389
45
165
385
53
53
53
55
57
59
61
83
261
93
83
95
261
93
163
195
201
231
299
309
313
325
329
363
401
419
91
175
191
197
205
209
233
237
245
299
305
309
313
317
321
363
367
07
07
42
03
04
15
16
37
06
04
08
04
41
10
24
17
16
09
16
09
07
38
06
00
44
12
05
21
07
15
12
15
23
02
45
02
36
02
06
30
11
04
04
17
12
02
17
12
02
09
08
27
15
05
08
10
01
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L10465
L10465
L120041
L120041
L120041
L120047
L276632
L277484
L400207
L400207
L400207
L400207
L400207
L400207
L400398
L400398
L400425
L400425
L400425
L400425
L400425
L400425
L400425
L400425
L400929
L40165
L40347
L40347
L41179
L41261
L41770
L41770
L41848
L41848
L42342
L43221
L43221
L43964
L43965
L441010
L441010
L442004
L442004
L442059
L442059
L442059
L443004
L443011
L443011
L443022
L444001
L444001
L444002
L444002
L444004
L444004
L444005
369
419
101
103
105
107
207
89
175
183
211
221
315
319
405
415
393
395
397
399
402
407
409
411
391
311
313
329
93
65
331
419
49
51
69
87
89
85
71
87
89
87
89
101
103
105
247
313
329
289
115
273
247
249
91
265
257
01
21
18
11
10
02
15
15
12
02
02
02
11
06
14
14
03
24
02
02
03
03
24
21
05
17
44
35
26
02
12
05
10
34
03
22
19
07
11
16
14
03
02
08
17
20
03
01
01
06
12
10
11
09
04
01
04
Part
No.
Page
No.
Ref.
No.
L444005
L444008
L444008
L444008
L444010
L444010
L444010
L444011
L444011
L444011
L444011
L444012
L444012
L444012
L444012
L444060
L444060
L444080
L445001
L445001
L445001
L445001
L445001
L445002
L445003
L445004
L445004
L445005
L445007
L445011
L445013
L445013
L445090
L445090
L445090
L445090
L446001
L446014
L446017
L446017
L446020
L446020
L446020
L446020
L446024
L446024
L446024
L446026
L446034
L446034
L446042
L446044
L446047
L446048
L446048
L446048
L446049
259
247
405
415
303
311
313
323
325
327
329
247
279
283
287
247
249
247
289
317
319
321
331
247
69
399
419
299
115
331
65
267
271
273
289
303
87
115
405
415
89
271
273
305
65
263
267
247
271
321
265
259
87
247
281
285
249
04
34
13
13
02
26
26
19
20
18
12
31
04
11
11
09
10
16
02
07
03
09
03
18
10
18
36
03
06
18
09
03
18
09
05
06
28
02
26
26
04
09
16
03
15
02
09
33
11
11
09
18
26
15
13
13
06
423
Part
No.
Page
No.
Ref.
No.
L446049
L446049
L446049
L446049
L447005
L447034
L447034
L448002
L448002
L450002
L47212
L47263
L47265
L47270
L47270
L48179
L48805
L48805
L48806
L48868A
L49618
L49618
L49619
L49619
L49725
L500001
L500001
L500001
L500002
L500004
L500004
L500004
L500005
L500008
L500009
L500011
L500013
L500013
L500013
L500014
L500016
L500017
L500017
L500017
L500019
L500019
L500019
L500020
L500021
L500022
L500023
L500024
L500024
L500024
L500025
L500026
L500026
253
253
279
399
93
275
281
87
297
333
331
391
391
139
139
369
315
319
419
381
183
195
183
195
105
29
31
33
31
29
31
33
31
31
31
31
31
31
31
31
31
35
43
47
35
37
39
27
27
27
35
35
37
39
27
35
37
05
06
11
20
32
11
04
18
11
04
06
06
07
01
01
13
03
23
25
08
05
13
06
14
21
15
08
17
05
13
07
13
21
04
03
01
16
16
18
10
06
01
02
01
03
03
04
11
12
13
07
08
08
09
06
10
10
907878/DP0208
Numerical Index
Part
No.
Page
No.
L500027
L500027
L500027
L500028
L500028
L500028
L500029
L500029
L500030
L500030
L500030
L500031
L500031
L500031
L500032
L500032
L500033
L500034
L500034
L500036
L500036
L500037
L500037
L500037
L500038
L500038
L500038
L500039
L500040
L500042
L500042
L500042
L500043
L500046
L500049
L500052
L500055
L500055
L500057
L500057
L500058
L500059
L500059
L500059
L500060
L500064
L500067
L500068
L500069
L500070
L500071
L500072
L500075
L500076
L500077
L500078
L500080
27
35
37
27
35
37
35
37
27
35
37
27
35
37
27
34
34
41
43
41
43
41
43
47
41
43
47
41
41
41
43
47
41
41
23
23
21
34
21
34
21
23
55
59
21
21
23
21
21
23
23
23
23
23
23
23
21
907878/DP0208
Ref.
No.
08
11
11
07
12
12
13
13
04
14
14
05
15
15
01
02
01
07
01
05
03
14
08
05
15
09
06
02
10
13
17
20
04
16
15
10
20
04
21
03
23
05
33
23
00
00
12
24
22
21
20
19
06
09
01
03
00
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L500080
L500081
L500081
L500082
L500082
L500083
L500084
L500086
L500087
L500088
L500089
L500090
L500091
L500092
L500093
L500094
L500095
L500096
L500097
L500098
L500099
L500099
L500101
L500101
L500102
L500104
L500106
L500108
L500108
L500109
L500110
L500111
L500112
L500113
L500114
L500116
L500116
L500117
L500120
L500124
L500125
L500126
L500127
L500128
L500129
L500131
L500132
L500133
L500134
L500135
L500136
L500136
L500137
L500137
L500138
L500138
L500139
65
21
67
23
45
45
45
45
45
45
45
45
45
45
45
45
45
45
45
47
29
33
29
29
29
31
29
29
31
27
29
27
29
29
43
35
37
34
45
23
23
351
351
351
351
351
351
351
351
351
53
57
53
57
53
57
53
19
00
25
11
01
02
03
05
06
07
08
09
10
11
12
13
14
16
17
27
08
04
03
09
01
09
00
19
15
02
14
10
16
00
07
00
00
00
00
13
14
04
09
01
02
08
06
03
07
05
05
05
04
04
02
02
01
Part
No.
Page
No.
L500139
L500143
L500143
L500145
L500145
L500146
L500146
L500147
L500147
L500147
L500147
L500148
L500148
L500148
L500148
L500149
L500149
L500150
L500150
L500150
L500150
L500151
L500151
L500151
L500151
L500152
L500152
L500152
L500152
L500157
L500157
L500158
L500158
L500159
L500159
L500159
L500159
L500160
L500160
L500160
L500160
L500161
L500161
L500161
L500161
L500162
L500162
L500162
L500162
L500163
L500163
L500163
L500163
L500164
L500164
L500165
L500165
57
53
57
53
57
53
57
53
55
57
59
53
55
57
59
53
57
53
55
57
59
53
55
57
59
53
55
57
59
55
59
57
59
53
55
57
59
53
55
57
59
53
55
57
59
53
55
57
59
53
55
57
59
53
57
53
57
424
Ref.
No.
01
11
11
11
11
11
11
26
18
26
18
25
17
25
17
11
11
21
15
21
15
18
14
18
14
20
13
20
13
07
07
12
06
14
05
14
05
13
04
13
04
22
03
22
03
19
02
19
02
23
01
23
01
09
09
08
08
Part
No.
Page
No.
Ref.
No.
L500166
L500166
L500167
L500167
L500168
L500168
L500169
L500189
L500196
L500197
L500210
L500212
L500213
L500216
L500218
L500220
L500221
L500223
L500224
L500225
L500227
L500227
L500228
L500230
L500231
L500242
L500243
L500243
L500244
L500245
L500247
L500252
L500262
L500265
L500265
L500266
L500266
L500266
L500267
L500267
L500267
L500268
L500269
L500280
L500280
L500281
L500281
L500286
L500287
L500295
L500296
L500300
L500300
L500300
L500311
L500312
L500339
53
57
53
57
53
57
23
416
407
407
413
415
402
399
405
401
415
405
93
21
87
89
23
411
411
381
352
361
21
21
73
361
375
143
155
143
155
167
143
155
167
41
41
143
155
143
155
183
183
149
149
343
345
351
85
85
81
07
07
06
06
10
10
22
01
01
01
24
01
01
05
01
24
00
00
08
13
10
11
03
01
01
01
01
06
00
00
21
05
11
03
03
02
02
08
03
03
20
12
11
04
04
04
04
00
00
19
19
17
08
10
09
10
17
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L500347
L500348
L500349
L500350
L500352
L500352
L500355
L500355
L500355
L500357
L500357
L500359
L500360
L500361
L500364
L500365
L500367
L500367
L500370
L500371
L500374
L500375
L500376
L500376
L500376
L500376
L500379
L500380
L500380
L500381
L500382
L500383
L500383
L500384
L500384
L500385
L500385
L500386
L500387
L500387
L500388
L500388
L500388
L500388
L500389
L500390
L500391
L500392
L500393
L500393
L500393
L500394
L500394
L500395
L500396
L500397
L500397
247
247
247
415
87
297
41
41
41
357
359
41
41
359
379
379
379
382
382
355
403
115
141
141
153
153
153
141
153
141
141
141
153
141
153
141
153
143
143
155
147
147
159
159
149
149
149
149
141
149
153
150
160
153
153
141
153
37
36
38
01
19
14
00
01
03
01
08
03
01
01
01
03
05
04
06
01
01
00
01
17
01
17
28
31
30
32
35
36
32
37
33
38
31
08
11
13
08
08
08
08
01
02
12
14
04
16
04
06
06
03
16
29
28
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L500398
L500398
L500398
L500398
L500403
L500403
L500430
L500439
L500440
L500444
L50050
L50050
L50050
L50051
L500548
L50056
L500569
L500570
L500570
L500571
L500571
L500573
L500573
L500574
L500574
L500575
L500575
L500576
L500576
L500577
L500577
L500578
L500579
L500580
L500580
L50059
L500591
L500592
L500593
L500594
L500595
L500596
L500598
L500600
L500601
L500602
L500602
L500603
L500603
L500604
L500604
L500605
L500606
L500607
L500608
L500608
L500608
53
55
57
59
53
55
247
65
119
93
83
83
93
51
23
73
25
53
55
53
57
53
57
53
55
53
55
53
55
53
55
53
53
53
55
81
61
61
61
61
61
61
93
129
125
125
129
125
129
125
129
129
81
31
141
141
153
11
16
11
16
40
28
39
22
01
20
19
46
03
16
08
10
20
29
22
28
28
30
29
31
24
32
23
33
20
34
19
27
12
35
21
06
01
02
03
04
09
10
20
42
01
13
13
14
14
30
30
01
18
20
01
17
01
Part
No.
Page
No.
Ref.
No.
L500608
L50061
L50061
L50061
L500610
L500610
L500615
L500615
L500615
L500615
L500617
L500617
L500618
L500618
L500618
L500619
L500619
L500640
L500640
L500652
L500652
L500653
L500653
L500656
L500656
L500657
L500658
L500658
L50066
L50066
L500660
L500664
L500664
L500665
L500665
L500666
L500666
L500680
L500688
L500688
L500689
L500689
L500690
L500690
L500691
L500691
L500692
L500692
L500694
L500695
L500695
L500695
L500696
L500696
L500696
L500697
L500697
153
63
85
333
141
153
144
145
156
157
143
155
143
155
165
143
155
150
160
355
357
355
357
355
357
81
147
159
69
111
420
53
55
53
55
53
55
31
355
357
355
357
355
357
355
357
355
357
29
29
31
33
29
31
33
29
31
17
08
17
03
23
23
10
11
10
11
01
01
13
15
24
17
19
02
02
06
05
11
10
04
03
09
07
07
05
20
01
41
30
42
29
43
31
02
03
02
05
04
08
07
09
08
07
06
12
17
17
15
14
18
16
07
12
425
Part
No.
Page
No.
Ref.
No.
L500697
L500698
L500699
L500700
L500700
L500701
L500701
L500702
L500703
L500703
L500704
L500705
L500706
L500706
L500707
L500707
L500708
L500708
L500709
L500709
L500709
L500710
L500711
L500711
L500712
L500712
L500713
L500714
L500715
L500716
L500717
L500718
L500718
L500719
L500719
L500720
L500721
L500722
L500723
L500724
L500725
L500726
L500728
L500745
L500746
L500747
L500748
L500750
L500751
L500751
L500752
L500753
L500754
L500755
L500757
L500758
L500759
33
31
31
29
33
29
33
29
29
33
31
31
29
33
29
33
29
31
29
31
33
31
29
33
29
31
27
31
29
31
31
29
33
29
33
63
378
378
378
378
378
378
233
347
347
25
25
31
369
377
375
375
375
375
375
375
149
11
14
13
04
06
18
14
03
01
02
05
03
05
07
02
03
19
15
06
11
08
16
10
09
19
15
02
01
00
10
09
16
18
09
12
21
04
03
06
05
02
07
12
01
03
21
17
17
08
06
03
03
05
05
06
04
19
907878/DP0208
Numerical Index
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
Part
No.
Page
No.
Ref.
No.
L500760
L500761
L500762
L500763
L500764
L500764
L500784
L500784
L500784
L500784
L500785
L500785
L500786
L500786
L500786
01
L500787
L500789
L500790
L500791
L500792
L500793
L500794
L500795
L500796
L500797
L500798
L500799
L500801
L500802
L500803
L500804
L500805
L500806
L500807
L500808
L500809
L50081
L500810
L500811
L500812
L500813
L500814
L500815
L500816
L500817
L500818
L500819
L500822
L500823
L500824
L500825
L500826
L500827
L500828
L500829
L500830
149
382
382
382
393
407
307
311
323
327
141
153
150
160
19
03
02
01
06
06
25
01
20
01
21
21
10
10
172
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
165
25
165
165
165
165
165
165
165
165
167
167
167
167
167
167
167
167
167
167
167
01
05
06
07
09
10
12
13
14
15
16
17
19
20
21
22
23
26
27
29
30
06
31
33
34
36
37
38
39
40
01
02
05
07
09
10
11
12
13
14
15
L500831
L500832
L500833
L500835
L500836
L500837
L500838
L500839
L500839
L50084
L50084
L50084
L50084
L50084
L500840
L500840
L500841
L500841
L500842
L500842
L500843
L500843
L500844
L500844
L500845
L500845
L500846
L500846
L500847
L500847
L500848
L500848
L500849
L500849
L500850
L500850
L500851
L500851
L500852
L500852
L500853
L500853
L500854
L500854
L500855
L500855
L500856
L500856
L500857
L500858
L500859
L500860
L500861
L500862
L500863
L500864
L500865
167
167
167
167
167
167
168
168
169
91
139
163
299
301
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
169
168
170
170
170
170
170
170
170
170
16
17
18
22
23
24
01
02
02
02
12
12
19
11
03
03
04
04
05
05
06
06
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
07
08
08
09
09
10
10
11
01
02
03
04
05
06
07
08
907878/DP0208
Part
No.
Page
No.
Ref.
No.
L500866
L500867
L500868
L500869
L500870
L500871
L500872
L500873
L500874
L500875
L500876
L500877
L500878
L500879
L500880
L500881
L500882
L500883
L500884
L500885
L500886
L500887
L500889
L500890
L500891
L500892
L500893
L500894
L500895
L500896
L500897
L500898
L500899
L500900
L500901
L500902
L500903
L500904
L500905
L500906
L500907
L500908
L500909
L500910
L500910
L500911
L500911
L500912
L500912
L500913
L500913
L500914
L500914
L500915
L500915
L500916
L500916
170
170
170
170
171
171
171
171
171
171
171
171
171
173
173
173
173
173
173
173
173
173
172
172
172
172
172
172
172
172
172
172
172
172
172
172
172
172
167
167
169
169
169
147
159
147
159
147
159
147
159
147
159
147
159
147
159
09
10
12
13
01
02
03
04
05
06
07
08
09
01
02
03
04
05
06
07
08
09
02
03
04
07
08
09
10
11
14
15
16
17
18
19
20
21
18
23
01
11
12
01
01
02
02
03
03
04
04
05
05
06
06
08
08
426
Part
No.
Page
No.
Ref.
No.
L500917
L500917
L500918
L50092
L50092
L50092
L50092
L50092
L50092
L50092
L50092
L50092
L50092
L500940
L500941
L500942
L500966
L500967
L500968
L500969
L50101
L50105
L50136
L50136
L50137
L50137
L50137
L50137
L50137
L50139
L50141
L50141
L50141
L50143
L50145
L50147
L50147
L50147
L50151
L50152
L50156
L50156
L50157
L50157
L50157
L50157
L50170
L50174
L50196
L50200
L50201
L50201
L50202
L50202
L50208
L50208
147
159
141
183
193
197
199
221
229
233
235
239
09
09
40
14
21
26
21
14
21
26
15
16
16
00
02
05
21
20
01
01
21
08
07
07
08
17
08
06
23
20
08
09
01
13
24
18
02
03
16
05
05
01
04
47
04
38
13
15
06
09
14
42
24
12
12
32
385
385
385
47
43
267
21
65
25
177
215
55
57
59
61
67
67
73
73
81
111
67
63
189
271
21
111
315
319
309
313
325
329
305
85
73
139
139
165
95
99
25
55
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L50209
L50211
L50217
L50228
L50228
L50228
L50230
L50235
L50235
L50236
L50236
L50242
L50251
L50251
L50253
L50253
L50261
L50261
L50261
L50261
L50261
L50273
L50273
L50273
L50275
L50277
L50277
L50282
L50283
L50283
L50283
L50284
L50284
L50284
L50286
L50286
L50288
L50288
L50292
L50294
L50294
L50294
L50294
L50300
L50301
L50305
L50313
L50313
L50333
L50359
L50364
L50364
L50367
L50368
L50368
L50371
L50371
93
60
69
95
99
333
91
307
309
57
61
402
179
189
139
163
63
395
397
409
411
395
399
413
91
271
311
321
21
271
273
416
417
420
405
415
87
419
81
393
395
407
409
21
21
93
315
319
402
109
67
253
109
109
111
21
401
27
06
17
11
07
06
07
09
18
15
05
10
06
03
03
03
10
21
27
21
24
08
33
25
14
02
19
05
17
04
04
04
04
06
11
11
17
06
13
04
25
05
25
02
05
15
04
02
04
15
19
13
01
07
18
06
02
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L50371
L50371
L50371
L50371
L50380
L50385
L50403
L50422
L50452
L50458
L50461
L50462
L50462
L50462
L50463
L50463
L50463
L50463
L50486
L50486
L50486
L50486
L50486
L50491
L50491
L50517
L50519
L50535
L50545
L50561
L50562
L50562
L50562
L50565
L50592
L50603
L50607
L50607
L50608
L50608
L50608
L50608
L50628
L50645
L50646
L50646
L50655
L50679
L50684
L50684
L50684
L50684
L50706
L50718
L50718
L50718
L50718
405
413
415
419
177
91
177
93
65
361
83
205
209
245
175
191
211
227
75
309
313
325
329
177
215
73
211
255
251
273
93
109
402
71
111
81
69
81
175
211
315
319
85
115
209
245
25
269
139
163
299
301
93
395
397
409
411
20
02
20
22
27
03
34
18
20
01
07
01
07
05
01
01
12
06
04
15
07
15
24
06
06
05
06
04
05
07
13
08
17
10
04
20
02
03
11
03
07
04
14
18
12
12
15
08
10
11
20
10
28
22
25
22
27
Part
No.
Page
No.
Ref.
No.
L50727
L50741
L50743
L50743
L50744
L50745
L50801
L50801
L50801
L50801
L50801
L50801
L50815
L50815
L50819
L50820
L50823
L50823
L50823
L50835
L50835
L50836
L50836
L50841
L50841
L50841
L50856
L50873
L50875
L50876
L50876
L50877
L50878
L50884
L50895
L50896
L50896
L50896
L50952
L50952
L50956
L50982
L50982
L50982
L50986
L50986
L510003
L510003
L510003
L510008
L510041
L510046
L510046
L51034
L51035
L51099
L51099
109
275
281
291
285
277
307
309
395
397
409
411
405
415
109
109
69
73
111
177
215
63
181
60
405
415
107
115
402
257
259
307
291
307
399
25
397
411
93
109
175
395
397
409
207
243
393
397
407
185
73
67
67
359
329
101
103
17
10
11
02
04
13
16
36
17
24
17
25
15
15
18
02
11
18
12
15
15
13
03
01
04
04
10
09
07
07
07
05
13
23
11
14
17
08
00
16
16
02
10
02
04
04
04
03
05
05
04
09
12
07
33
20
03
427
Part
No.
Page
No.
Ref.
No.
L51099
L51587
L51587
L51590
L51591
L51591
L51599
L51599
L51621
L51621
L51621
L51781
L51972
L51972
L520003
L520003
L520003
L520003
L520004
L520005
L520019
L520019
L52026
L52026
L52026
L52026
L52027
L52048
L52048
L530003
L530004
L560003
L560003
L580009
L580009
L580009
L580009
L60198
L60198
L60198
L60451
L60451
L60492
L60492
L60587
L60653
L60653
L60653
L60653
L60961
L60986
L60986
L60986
L60986
L60986
L60986
L60986
105
87
297
271
65
267
311
313
271
331
333
105
247
249
399
401
413
419
185
99
175
245
63
65
177
215
49
177
215
85
175
183
221
71
83
83
93
139
139
163
405
415
103
107
81
277
279
283
287
391
247
257
259
259
303
307
309
08
20
15
13
08
02
27
24
23
04
02
06
13
14
13
07
07
26
02
19
02
06
15
07
11
11
02
05
05
06
05
11
11
08
20
45
05
01
01
01
22
22
09
13
00
08
03
12
08
08
24
04
03
16
11
27
33
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L60986
L60986
L60986
L61001
L61017
L61092
L61287
L61287
L61307
L61307
L61307
L61307
L61317
L61317
L61411
L61411
L61699
L61699
L61699
L61699
L61699
L61699
L61708
L61708
L61708
L61708
L61708
L61708
L61708
L61708
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
311
313
361
391
391
333
397
411
395
397
409
411
381
397
405
415
185
189
195
223
231
241
177
179
181
197
215
217
219
233
177
179
181
187
193
193
195
195
197
199
201
201
203
215
217
219
225
229
229
231
231
233
235
237
237
239
315
25
20
02
02
03
20
23
26
04
11
04
11
01
16
23
23
07
04
17
07
17
11
20
01
10
05
20
01
10
05
21
08
09
01
02
07
02
04
02
04
02
07
04
21
08
09
01
02
07
02
04
02
04
02
07
04
23
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L61709
L61709
L61709
L61709
L61709
L61866
L61866
L62026
L62026
L62026
L62026
L62715
L62715
L62715
L62731
L62731
L62732
L62732
L62732
L62732
L62733
L62734
L62761
L62842
L62954
L62954
L630003
L630004
L63015
L63015
L63016
L63016
L63017
L63018
L63018
L63143
L63233
L63275
L63275
L63439
L63439
L63439
L63468
L63475
L63475
L63546
L63548
L63593
L63605
L63714
L63715
L63716
L63716
L63716
L63717
L63717
L63717
319
395
397
409
411
401
413
395
397
409
411
177
179
239
179
217
179
195
217
231
177
193
355
247
87
297
85
85
299
363
299
363
369
305
369
399
399
299
301
101
103
105
399
197
233
87
23
379
93
325
299
299
399
402
309
313
325
18
19
22
19
19
05
05
10
12
10
13
19
04
10
02
02
03
10
03
09
16
04
02
06
08
10
02
01
04
00
17
01
10
07
03
07
27
22
15
18
11
10
35
06
06
11
23
02
19
28
13
12
25
11
19
12
27
Part
No.
Page
No.
Ref.
No.
L63717
L63719
L63720
L63756
L63887
L63951
L63970
L63970
L63983
L63984
L63994
L63995
L64078
L64122
L64132
L64132
L64132
L64132
L64143
L64175
L64294
L64294
L64294
L64294
L64294
L64294
L64359
L64359
L64359
L64359
L64360
L64360
L64367
L64367
L64367
L64384
L64384
L64384
L64384
L64466
L64466
L64467
L64467
L64467
L64467
L64468
L64468
L64468
L64468
L64524
L64524
L64559
L64559
L64561
L64561
L64561
L64561
329
307
307
25
49
399
379
399
399
399
399
399
73
381
177
181
215
219
177
381
395
397
405
409
411
415
177
183
215
221
183
221
299
363
373
177
183
215
221
183
221
183
187
221
225
177
183
215
221
65
267
317
321
393
395
397
399
21
21
20
03
19
34
00
17
19
10
30
15
00
02
23
05
23
05
22
08
07
07
02
07
02
02
26
13
26
13
04
04
02
11
01
29
18
29
18
12
12
16
05
16
05
30
19
30
19
16
10
04
02
02
26
04
04
428
Part
No.
Page
No.
Ref.
No.
L64561
L64561
L64561
L64646
L64660
L64660
L64660
L64660
L64663
L64664
L64764
L64787
L64795
L64795
L64853
L64853
L64856
L64856
L64890
L64914
L64934
L64934
L64963
L65097
L65097
L65098
L65098
L65167
L65180
L65180
L65180
L65180
L65181
L65181
L65181
L65181
L65211
L65211
L65223
L65223
L65223
L65223
L65223
L65223
L65273
L65273
L65338
L65338
L65568
L65570
L65638
L65638
L65638
L65638
L65640
L65640
L65640
407
409
411
93
247
251
405
415
93
93
107
103
93
115
115
333
247
249
69
91
183
221
91
209
245
209
245
397
395
397
409
411
395
397
409
411
87
89
393
395
397
407
409
411
395
409
405
415
93
93
177
193
215
229
177
193
215
02
26
22
07
27
08
03
03
04
02
07
02
08
03
15
17
02
01
16
15
20
20
17
13
13
14
14
21
14
18
14
15
03
14
03
07
24
18
02
26
04
02
26
22
05
05
18
18
00
00
08
13
08
13
03
12
03
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L65640
L65689
L65689
L65753
L66011
L66017
L66017
L66017
L66017
L66017
L66017
L66406
L66453
L66453
L66456
L66456
L66576
L66576
L66594
L66594
L66594
L66780
L66780
L66782
L66782
L66783
L66783
L66783
L66783
L66783
L66783
L66805
L66805
L66809
L66809
L66811
L66811
L66831
L66831
L66885
L66885
L66918
L66919
L66931
L66946
L66946
L66949
L66950
L66958
L66986
L66993
L67099
L67099
L67100
L67100
L67105
L67105
229
401
413
265
25
395
395
397
409
409
411
391
209
245
209
245
273
345
101
103
105
187
225
187
225
187
199
203
225
235
239
401
413
401
413
401
413
401
413
301
361
402
402
402
405
415
402
402
399
25
25
207
243
207
243
207
243
12
23
23
02
22
11
13
06
11
13
09
04
11
11
15
15
17
01
19
13
09
07
07
08
08
09
16
09
09
16
09
27
27
26
26
08
08
17
17
16
00
15
05
06
19
19
20
19
08
11
13
11
11
11
11
10
10
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L67106
L67106
L67107
L67107
L67119
L67120
L67239
L67246
L67246
L67248
L67248
L67248
L67248
L67258
L67267
L67341
L67341
L67341
L67341
L67341
L67341
L67347
L67347
L67379
L67379
L67440
L67446
L67446
L67446
L67446
L67446
L67446
L67446
L67448
L67448
L67489
L67491
L67494
L67495
L67495
L67495
L67510
L67514
L67576
L67577
L67598
L67598
L67599
L67599
L67608
L67609
L67610
L67611
L67620
L67624
L67740
L67749
207
243
207
243
375
375
413
401
413
383
401
413
419
419
413
307
309
311
323
325
327
401
413
111
113
317
307
309
311
315
323
325
327
207
243
419
419
419
401
413
419
419
419
419
419
401
413
401
413
419
419
419
419
417
417
419
419
09
09
14
14
02
08
27
04
04
00
15
15
34
27
26
07
48
06
07
41
05
01
01
25
21
14
06
49
07
28
06
42
06
07
07
31
23
16
12
12
33
09
03
15
14
13
13
14
14
11
10
13
12
00
00
20
17
Part
No.
Page
No.
Ref.
No.
L67802
L68003
L68039
L68039
L68039
L68046
L68110
L68128
L68133
L68331
L68337
L68337
L68349
L68349
L68349
L68496
L68516
L68517
L68569
L68585
L68711
L68804
L68804
L68804
L68831
L68881
L68881
L68882
L68882
L69010
L69011
L69012
L69015
L69016
L69079
L69081
L69085
L69095
L69099
L69100
L69101
L69114
L69115
L69123
L69125
L69125
L69127
L69127
L69128
L69131
L69135
L69135
L69136
L69137
L69138
L69138
L69138
419
305
303
305
311
205
333
333
83
391
382
402
189
223
241
73
105
101
63
85
338
279
283
287
403
299
301
299
301
139
139
65
139
139
67
67
67
67
67
67
67
163
21
109
303
367
307
371
267
99
303
367
373
21
91
301
303
40
11
13
18
15
04
21
23
29
09
00
16
08
03
03
12
11
06
23
10
00
06
05
04
02
26
19
24
17
15
15
18
15
15
06
07
03
04
15
05
17
01
03
13
01
00
18
09
01
01
01
00
00
13
18
14
20
429
Part
No.
Page
No.
Ref.
No.
L69138
L69138
L69138
L69139
L69139
L69142
L69142
L69144
L69144
L69144
L69146
L69149
L69149
L69155
L69156
L69162
L69166
L69167
L69167
L69226
L69232
L69238
L69240
L69240
L69241
L69241
L69264
L69265
L69275
L69275
L69275
L69279
L69280
L69281
L69282
L69283
L69284
L69285
L69286
L69287
L69289
L69290
L69297
L69300
L69303
L69303
L69303
L69304
L69304
L69304
L69305
L69306
L69306
L69306
L69309
L69309
L69311
365
367
377
305
369
303
367
311
313
371
373
305
369
67
373
67
89
416
417
67
67
67
93
109
93
109
93
109
139
299
301
73
73
49
49
49
49
49
49
49
49
49
25
49
101
103
105
101
103
105
373
101
103
105
87
297
99
01
10
07
01
00
07
03
21
19
00
00
01
00
18
00
08
23
03
03
14
16
11
09
11
10
10
17
14
11
16
09
20
22
18
03
14
06
15
17
16
12
05
23
08
13
19
17
11
18
18
00
09
16
19
19
14
24
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L69324
L69351
L69351
L69353
L69355
L69358
L69360
L69382
L69382
L69382
L69392
L69392
L69395
L69395
L69395
L69400
L69400
L69402
L69447
L69448
L69449
L69450
L69451
L69452
L69453
L69465
L69465
L69466
L69466
L69467
L69467
L69467
L69467
L69467
L69468
L69473
L69474
L69474
L69474
L69474
L69475
L69475
L69480
L69480
L69480
L69480
L69485
L69485
L69486
L69486
L69488
L69489
L69489
L69490
L69490
L69492
L69492
109
95
99
99
67
87
89
139
299
301
67
71
251
253
337
109
111
49
319
319
311
311
327
311
311
83
333
49
51
281
283
285
287
346
83
83
175
191
211
227
273
343
175
211
315
319
315
319
315
319
83
49
51
49
51
175
191
12
10
09
03
22
27
20
13
18
12
21
05
01
04
01
03
23
19
21
11
30
31
04
05
04
03
14
25
01
10
07
05
12
00
35
34
03
03
13
07
01
00
15
07
10
07
13
16
02
22
33
27
03
28
04
19
12
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L69492
L69492
L69499
L69524
L69524
L69524
L69524
L69525
L69525
L69534
L69534
L69538
L69540
L69542
L69543
L69545
L69546
L69548
L69549
L69551
L69557
L69557
L69558
L69558
L69564
L69564
L69565
L69565
L69567
L69570
L69570
L69570
L69571
L69572
L69572
L69576
L69576
L69576
L69577
L69578
L69578
L69584
L69584
L69584
L69590
L69595
L69596
L69599
L69600
L69601
L69601
L69607
L69615
L69619
L69624
L69625
L69627
211
227
247
185
197
223
233
189
241
211
227
107
107
67
247
73
49
49
49
49
303
305
303
305
303
367
303
367
107
101
103
105
247
69
266
143
155
263
263
87
89
101
103
105
69
65
65
303
303
311
313
71
71
71
85
85
85
16
03
04
03
25
03
23
08
03
10
02
12
11
02
22
19
21
24
23
22
12
22
21
17
09
00
09
00
15
03
14
03
14
12
01
23
25
01
03
10
11
01
10
01
14
03
01
18
08
18
16
07
04
02
20
13
16
Part
No.
Page
No.
Ref.
No.
L69629
L69634
L69636
L69665
L69686
L69687
L69695
L69696
L69712
L69714
L69714
L69714
L69718
L69723
L69723
L69724
L69724
L69724
L69724
L69724
L69724
L69724
L69724
L69724
L69724
L69725
L69725
L69725
L69725
L69725
L69727
L69727
L69727
L69728
L69728
L69728
L69728
L69729
L69731
L69732
L69733
L69734
L69734
L69734
L69734
L69735
L69736
L69739
L69740
L69741
L69747
L69747
L69751
L69751
L69751
L69755
L69756
85
71
87
99
93
93
93
93
107
101
103
105
93
205
241
91
205
207
209
245
299
307
309
311
313
91
207
209
245
299
245
311
313
207
209
243
245
21
273
273
273
139
150
160
163
115
115
89
89
89
255
338
307
309
371
73
73
18
12
15
17
23
16
23
16
17
01
10
01
30
16
12
08
08
17
04
09
06
30
30
23
22
12
18
16
16
01
10
22
21
03
09
03
04
15
13
12
11
08
11
11
08
08
08
10
07
09
01
00
26
34
00
25
23
430
Part
No.
Page
No.
Ref.
No.
L69766
L69774
L69774
L69775
L69776
L69780
L69780
L69781
L69782
L69789
L69789
L69791
L69793
L69793
L69793
L69794
L69795
L69795
L69795
L69796
L69796
L69796
L69807
L69812
L69813
L69822
L69822
L69822
L69822
L69824
L69825
L69825
L69832
L69832
L69832
L69832
L69832
L69832
L69832
L69832
L69832
L69833
L69833
L69833
L69833
L69833
L69833
L69833
L69866
L69866
L69902
L69902
L69902
L69902
L69903
L69903
L69903
81
301
365
361
301
207
243
243
89
69
71
107
101
103
105
107
101
103
105
101
103
105
93
93
93
307
309
323
325
49
49
51
307
309
313
313
323
325
329
329
329
307
309
313
313
323
325
329
175
191
279
283
285
285
247
253
253
21
03
06
08
04
03
03
01
08
15
06
19
01
10
01
20
03
14
03
18
11
10
22
12
23
02
13
02
13
30
31
07
01
16
04
09
01
16
04
07
08
08
17
05
10
08
17
05
07
07
14
06
08
19
30
01
08
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69903
L69904
L69904
L69904
L69904
L69904
L69904
L69904
L69904
L69904
L69904
L69905
L69905
L69905
L69905
L69905
L69905
L69905
L69906
L69906
L69906
L69906
L69906
L69906
L69906
L69906
L69906
L69906
L69907
L69907
L69907
L69907
L69907
L69908
L69908
L69910
L69911
L69913
L69913
L69917
L69919
L69919
L69920
L69920
269
277
277
277
279
281
281
283
285
285
285
285
287
419
275
275
277
277
281
281
285
285
285
285
281
281
283
285
285
295
295
279
281
281
285
293
293
293
293
295
295
275
277
281
285
297
271
305
305
305
271
303
247
251
257
247
249
05
05
10
11
12
09
16
03
06
11
17
21
05
35
05
08
07
09
08
17
07
10
18
20
12
15
13
12
16
05
09
15
02
05
08
05
06
09
10
06
10
02
02
06
02
05
08
25
04
16
19
05
01
03
16
05
04
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L69920
L69920
L69920
L69920
L69920
L69920
L69920
L69921
L69921
L69921
L69922
L69922
L69924
L69924
L69925
L69925
L69925
L69926
L69926
L69926
L69927
L69927
L69927
L69928
L69928
L69928
L69928
L69929
L69929
L69929
L69929
L69930
L69930
L69930
L69931
L69931
L69931
L69932
L69932
L69933
L69933
L69933
L69934
L69934
L69934
L69935
L69935
L69935
L69936
L69936
L69936
L69936
L69937
L69937
L69937
L69938
L69938
275
277
277
281
285
285
297
269
299
299
269
297
247
269
65
267
269
69
251
266
69
266
297
293
295
297
297
69
257
259
266
251
293
295
247
251
251
247
269
65
267
297
65
247
267
65
255
267
65
257
259
267
255
257
259
331
333
03
03
15
14
09
15
04
04
10
11
09
06
30
05
10
04
06
08
06
04
07
05
02
07
07
03
07
13
08
08
06
12
08
08
29
07
15
28
10
13
07
01
14
32
08
11
07
05
12
13
13
06
03
09
09
19
07
Part
No.
Page
No.
Ref.
No.
L69939
L69939
L69939
L69939
L69939
L69940
L69940
L69940
L69940
L69940
L69942
L69942
L69944
L69945
L69946
L69947
L69947
L69952
L69963
L69964
L69965
L69968
L69968
L69973
L69975
L69976
L69976
L69979
L69980
L69981
L69982
L69983
L69984
L69985
L69986
L69994
L69994
L69994
L69994
L69996
L69996
L69997
L70008
L70008
L70009
L70014
L70014
L70014
L70014
L70015
L70017
L70017
L70031
L70033
L70033
L70039
L70040
255
257
259
263
263
257
259
263
265
265
257
259
311
327
319
311
327
205
205
205
205
205
209
205
205
307
309
315
315
315
315
307
307
323
323
175
211
315
319
183
221
361
251
337
81
275
277
281
285
73
21
51
49
247
251
21
177
06
15
15
05
06
10
10
04
07
08
05
05
01
01
15
11
10
06
14
11
05
09
03
10
02
17
35
21
15
22
16
10
11
10
11
13
04
06
05
07
07
03
02
06
26
01
01
03
01
24
09
11
07
20
11
19
13
431
Part
No.
Page
No.
Ref.
No.
L70040
L70040
L70040
L70041
L70045
L70055
L70064
L70065
L70067
L70075
L70075
L70083
L70083
L70083
L70084
L70084
L70084
L70084
L70086
L70087
L70087
L70088
L70090
L70092
L70094
L70095
L70095
L70096
L70098
L70100
L70102
L70105
L70107
L70111
L70113
L70116
L70116
L70120
L70121
L70123
L70128
L70128
L70128
L70129
L70130
L70133
L70146
L70149
L70162
L70173
L70176
L70177
L70178
L70179
L70180
L70182
L70183
193
215
229
81
83
23
83
83
83
21
61
115
331
333
269
269
301
301
305
115
333
311
311
311
307
307
323
315
307
307
323
327
327
323
323
23
45
65
21
21
139
299
301
99
99
115
85
85
83
89
305
305
85
85
85
305
69
00
13
00
18
05
02
24
11
12
13
11
13
17
18
11
12
06
07
30
04
19
29
01
01
25
03
03
14
25
25
20
01
01
20
20
03
18
04
13
13
11
16
09
16
05
07
08
12
18
05
06
09
04
05
03
28
04
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L70183
L70184
L70188
L70197
L70198
L70200
L70201
L70207
L70212
L70216
L70225
L70226
L70227
L70229
L70229
L70229
L70230
L70230
L70232
L70233
L70234
L70239
L70240
L70240
L70241
L70242
L70242
L70242
L70242
L70244
L70245
L70246
L70247
L70248
L70250
L70251
L70251
L70257
L70266
L70267
L70267
L70270
L70270
L70274
L70274
L70276
L70276
L70277
L70277
L70308
L70308
L70310
L70321
L70322
L70324
L70325
L70326
305
69
247
83
83
81
73
87
73
81
81
81
81
247
249
334
269
339
115
93
87
83
305
369
21
177
193
215
229
21
21
21
21
69
69
305
369
81
87
247
251
315
317
373
375
307
323
307
323
307
309
205
83
83
107
107
81
26
01
19
16
02
14
16
12
07
19
04
07
08
10
08
00
01
00
14
24
13
01
29
00
19
02
20
02
20
13
13
13
13
18
19
29
00
05
14
17
09
29
15
03
09
02
02
02
02
28
31
13
10
23
09
01
02
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L70333
L70335
L70338
L70344
L70345
L70358
L70358
L70359
L70366
L70377
L70377
L70378
L70378
L70379
L70385
L70388
L70388
L70388
L70389
L70390
L70391
L70392
L70394
L70395
L70396
L70400
L70402
L70403
L70404
L70406
L70412
L70413
L70414
L70415
L70415
L70415
L70415
L70415
L70415
L70416
L70417
L70420
L70420
L70420
L70420
L70428
L70428
L70429
L70429
L70435
L70435
L70443
L70448
L70449
L70450
L70452
L70453
107
107
87
25
25
301
365
115
207
87
297
87
297
87
299
21
87
89
89
87
60
333
333
333
60
333
93
21
115
21
107
93
49
76
77
257
257
259
259
49
25
175
211
315
319
257
259
177
193
69
71
105
115
73
73
73
73
03
05
25
07
05
01
00
17
01
01
17
07
09
21
05
08
02
01
03
05
02
15
12
22
05
01
08
00
17
00
18
06
04
06
05
01
03
01
03
13
04
17
11
12
10
02
02
33
22
20
09
16
19
13
14
17
15
Part
No.
Page
No.
Ref.
No.
L70455
L70456
L70460
L70461
L70462
L70463
L70465
L70465
L70467
L70467
L70467
L70468
L70468
L70468
L70470
L70471
L70486
L70486
L70486
L70486
L70493
L70493
L70493
L70495
L70495
L70496
L70497
L70497
L70501
L70501
L70502
L70502
L70514
L70514
L70521
L70528
L70565
L70568
L70575
L70576
L70581
L70582
L70586
L70588
L70589
L70592
L70605
L70614
L70615
L70616
L70618
L70618
L70619
L70621
L70625
L70625
L70629
89
89
303
105
215
21
87
247
101
103
105
101
103
105
105
21
27
35
37
51
247
249
253
361
363
99
297
333
49
51
367
371
257
259
93
289
71
71
89
305
139
139
83
83
247
73
91
91
91
91
91
377
83
91
95
99
95
21
22
04
05
13
19
29
21
02
12
02
04
15
04
07
18
09
02
02
15
08
12
11
09
12
02
13
08
26
02
09
10
12
12
19
01
03
01
16
12
04
04
14
17
35
11
01
10
13
22
19
03
28
09
00
23
18
432
Part
No.
Page
No.
Ref.
No.
L70629
L70632
L70632
L70632
L70632
L70633
L70633
L70634
L70635
L70635
L70635
L70635
L70639
L70639
L70639
L70639
L70647
L70649
L70649
L70651
L70651
L70652
L70653
L70655
L70655
L70655
L70655
L70655
L70656
L70657
L70677
L70682
L70684
L70686
L70688
L70688
L70688
L70688
L70689
L70689
L70690
L70690
L70690
L70690
L70691
L70691
L70691
L70691
L70692
L70692
L70692
L70693
L70693
L70694
L70694
L70695
L70695
99
307
309
323
325
315
317
73
177
193
215
229
177
193
215
229
99
31
99
352
353
103
103
381
395
397
409
411
103
103
63
93
103
103
283
287
291
291
291
291
249
249
291
291
91
91
289
289
87
289
297
249
289
249
289
91
91
21
03
01
03
01
14
10
03
25
00
25
00
12
00
12
00
20
22
10
04
04
06
04
01
12
16
12
10
07
08
07
12
08
08
04
03
06
08
05
07
05
11
09
10
06
21
08
09
31
04
19
02
12
03
03
05
20
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L70695
L70695
L70696
L70697
L70701
L70703
L70703
L70704
L70704
L70705
L70706
L70709
L70709
L70709
L70710
L70714
L70715
L70718
L70718
L70719
L70722
L70723
L70725
L70725
L70725
L70726
L70778
L70786
L70798
L70799
L70806
L70817
L70819
L70862
L70863
L70863
L70864
L70864
L70865
L70894
L70894
L70895
L70895
L70912
L70912
L70912
L70912
L70952
L70956
L70962
L70962
L70963
L70963
L70964
L70964
L70969
L70970
289
289
63
99
81
323
325
323
325
315
315
29
95
99
49
139
139
99
103
399
63
63
95
95
99
103
63
63
63
63
303
63
93
411
227
229
191
193
93
231
233
195
197
199
201
235
237
191
227
231
233
195
197
317
321
139
139
10
11
19
13
17
10
40
11
39
15
21
00
00
15
02
06
06
16
01
31
09
20
06
06
08
20
16
25
03
04
03
24
08
16
01
01
11
01
06
01
01
01
01
01
01
01
01
10
04
18
24
18
24
11
12
06
06
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L70972
L70972
L71000
L71000
L71000
L71000
L71001
L71001
L71001
L71001
L71001
L71001
L71001
L71001
L71003
L71003
L71003
L71003
L71004
L71004
L71005
L71006
L71006
L71006
L71006
L71006
L71006
L71006
L71006
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71007
L71008
L71008
L71008
L71008
L71008
L71008
L71008
L71008
L71010
L71010
L71010
L71010
L71011
L71011
L71011
L71011
193
317
193
199
229
235
193
197
199
203
229
233
235
239
199
203
235
239
193
229
193
193
197
199
203
229
233
235
239
193
197
199
199
203
203
229
233
235
235
239
239
195
197
199
201
231
233
235
237
309
313
325
329
199
203
235
239
11
06
17
18
17
18
16
11
12
13
16
11
12
13
02
02
02
02
14
14
15
19
16
14
11
19
13
14
11
18
14
13
19
12
14
18
14
13
19
12
14
12
19
08
15
12
19
08
15
50
49
43
40
15
08
21
08
Part
No.
Page
No.
Ref.
No.
L71014
L71014
L71014
L71014
L71016
L71016
L71016
L71016
L71017
L71017
L71020
L71020
L71020
L71020
L71020
L71020
L71023
L71023
L71024
L71024
L71027
L71027
L71028
L71028
L71029
L71030
L71031
L71032
L71033
L71034
L71035
L71035
L71036
L71036
L71037
L71037
L71038
L71039
L71040
L71040
L71041
L71041
L71042
L71042
L71042
L71042
L71043
L71043
L71046
L71046
L71047
L71048
L71050
L71051
L71055
L71055
L71071
309
313
325
329
309
313
325
329
197
233
193
195
201
229
231
237
321
375
317
375
307
309
307
309
317
317
329
329
313
313
313
329
309
313
309
313
313
313
325
329
325
329
309
313
325
329
313
329
313
329
309
325
317
321
309
325
73
07
50
07
41
03
46
03
37
18
18
05
08
05
05
08
05
01
00
01
00
10
47
11
46
09
16
02
03
02
03
36
09
12
43
11
42
29
30
12
26
11
27
14
08
14
25
27
14
35
28
26
19
08
10
40
33
21
433
Part
No.
Page
No.
Ref.
No.
L71072
L71073
L71074
L71074
L71075
L71075
L71076
L71076
L71076
L71077
L71077
L71077
L71078
L71078
L71079
L71079
L71080
L71080
L71081
L71081
L71082
L71082
L71083
L71083
L71084
L71084
L71085
L71085
L71086
L71086
L71088
L71095
L71104
L71104
L71104
L71104
L71104
L71146
L71147
L71159
L71160
L71161
L71165
L71166
L71166
L71168
L71172
L71172
L71175
L71176
L71193
L71204
L71204
L71205
L71205
L71206
L71206
73
73
49
51
49
51
49
51
51
49
49
51
49
51
49
51
49
51
49
51
49
51
49
51
49
51
49
51
49
51
49
49
307
309
313
325
329
21
73
391
391
391
305
301
361
83
83
99
89
93
83
183
221
183
221
183
195
20
22
18
31
03
18
14
27
28
06
06
21
15
29
17
30
16
30
12
25
05
20
08
23
07
22
04
19
13
26
11
02
22
37
31
32
19
00
19
11
12
13
30
16
00
08
25
20
22
04
32
20
20
03
03
07
16
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L71206
L71206
L71206
L71206
L71212
L71212
L71213
L71213
L71213
L71213
L71213
L71213
L71214
L71214
L71214
L71214
L71214
L71214
L71214
L71214
L71222
L71223
L71245
L71245
L71245
L71245
L71245
L71245
L71245
L71245
L71258
L71259
L71266
L71266
L71271
L71305
L71306
L71314
L71336
L71337
L71339
L71339
L71339
L71341
L71342
L71343
L71347
L71347
L71347
L71347
L71350
L71351
L71352
L71353
L71357
L71360
L71360
201
221
231
237
197
233
199
235
309
313
325
329
195
197
199
201
231
233
235
237
305
21
195
197
199
201
231
233
235
237
85
85
405
415
247
81
233
107
83
83
275
277
279
21
346
347
309
313
325
329
391
21
63
63
60
251
253
11
07
16
11
23
16
11
11
08
51
08
42
09
22
20
16
11
22
20
16
12
22
19
27
22
17
19
27
22
17
10
12
19
19
23
10
25
00
30
27
06
06
13
00
05
07
06
52
06
43
01
00
01
02
03
13
07
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L71360
L71360
L71389
L71389
L71389
L71389
L71390
L71390
L71391
L71391
L71412
L71413
L71415
L71419
L71421
L71421
L71421
L71421
L71425
L71454
L71520
L71527
L71546
L71547
L71550
L71553
L71564
L71577
L71577
L71595
L71651
L71651
L71674
L71691
L71691
L71691
L71705
L71705
L71705
L71705
L71707
L71708
L71709
L71709
L71715
L71716
L71717
L71718
L71720
L71721
L71723
L71725
L71726
L71729
L71732
L71733
L71733
275
277
309
313
325
329
325
329
309
313
115
87
359
233
309
313
325
329
378
273
61
175
205
205
205
75
75
139
163
81
399
419
61
49
51
75
309
313
325
329
251
419
49
51
63
63
63
63
61
63
139
76
76
76
76
253
335
09
14
05
48
05
39
10
34
10
34
16
09
07
25
39
33
31
18
00
03
00
18
04
02
13
03
02
01
01
18
26
37
12
20
24
01
43
39
36
31
01
07
02
17
01
02
05
06
11
22
01
03
02
00
05
10
01
Part
No.
Page
No.
Ref.
No.
L71733
L71747
L71747
L71747
L71747
L71748
L71748
L71748
L71748
L71749
L71750
L71751
L71752
L71754
L71755
L71758
L75956
L76020
L79117
L79167
L79167
L79167
L79167
L79167
L80937
L810005
L810005
L81233
L81233
L82358
L82358
L88976
L94770
L94818
L94824
L94849
L94849
L94849
L94849
L94849
L94849
L94849
L94849
L94849
L94856
L94898
L94898
L94898
L94898
L96060
L96060
L96060
L96060
L96060
L96060
L96060
L96060
336
309
313
325
329
309
313
325
329
253
76
77
77
63
63
139
89
93
89
189
213
241
311
327
93
397
411
251
277
405
415
9
118
118
135
123
123
125
125
127
127
129
129
131
121
123
125
127
129
123
123
125
125
127
127
129
129
01
42
38
35
30
44
40
37
32
12
04
07
06
05
06
01
24
14
06
09
03
09
02
02
00
28
18
16
12
09
09
00
10
11
06
08
23
08
22
08
22
08
21
08
03
34
32
34
32
14
29
15
28
14
29
15
28
434
Part
No.
Page
No.
Ref.
No.
L96060
L96065
L96065
L96065
L96065
L96065
L96065
L96065
L96065
L96065
L96066
L96066
L96066
L96066
L96066
L96066
L96066
L96066
L96066
L96580
L96838
L96838
L96838
L97358
L97359
L97359
L97359
L97359
L97362
L97362
L97516
L97616
L97616
L97616
L97768
L97769
L97839
L97889
L97889
L97889
L98029
L98266
L98266
L98266
L98266
L98266
L98266
L98266
L98266
L98266
L98266
L98312
L98425
L98457
L98503
L98506
L98507
131
123
123
125
125
127
127
129
129
131
123
123
125
125
127
127
129
129
131
351
367
371
381
343
343
343
343
343
343
345
134
151
161
172
381
381
381
361
363
381
343
123
123
125
125
127
127
129
129
132
132
117
118
363
363
363
363
15
03
18
03
17
03
18
03
17
03
04
19
04
18
04
19
04
18
04
02
09
10
08
04
04
06
09
11
09
03
03
10
10
13
01
07
04
09
12
08
11
30
36
29
34
30
36
29
34
04
08
32
09
07
03
13
06
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L98509
L98528
L98547
L98550
L98662
L98894
L98894
L98894
L98894
L98894
L98919
L98921
L98922
L98923
L98978
L99029
L99029
L99029
L99029
L99029
L99029
L99029
L99029
L99029
L99030
L99045
L99053
L99056
L99074
L99084
L99084
L99085
L99085
L99086
L99086
L99093
L99122
L99122
L99122
L99134
L99134
L99134
L99134
L99157
L99157
L99157
L99157
L99157
L99157
L99182
L99190
L99191
L99222
L99223
L99235
L99236
L99238
363
369
369
363
379
343
343
345
351
351
383
383
383
383
9
117
117
117
117
117
117
117
118
118
134
117
373
373
381
343
345
343
345
343
345
345
367
371
375
309
313
325
329
23
45
81
81
83
83
115
393
393
397
397
405
405
415
09
05
04
05
04
03
07
04
05
07
05
01
06
08
03
19
22
24
28
33
35
37
15
17
04
34
07
05
03
07
05
05
02
03
04
06
07
08
07
40
35
33
28
14
08
04
19
12
39
10
01
01
05
05
01
01
01
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L99269
L99285
L99285
L99285
L99405
L99405
L99405
L99420
L99425
L99434
L99440
L99440
L99441
L99453
L99453
L99453
L99453
L99454
L99456
L99457
L99459
L99459
L99459
L99461
L99461
L99462
L99462
L99465
L99465
L99466
L99466
L99466
L99467
L99467
L99468
L99468
L99469
L99469
L99469
L99470
L99470
L99471
L99471
L99471
L99472
L99472
L99473
L99473
L99474
L99474
L99475
L99475
L99477
L99477
L99478
L99478
L99478
117
117
118
118
363
369
381
9
65
107
9
117
119
9
101
103
105
73
141
141
9
87
297
141
153
141
153
141
153
141
153
165
141
153
141
153
141
153
165
141
153
141
153
165
141
153
141
153
141
153
141
153
141
153
141
153
165
25
36
16
18
04
08
05
02
18
16
09
40
01
07
15
22
14
02
34
41
08
19
14
01
01
02
02
14
05
06
06
08
07
07
08
08
09
09
35
15
10
05
11
32
12
12
13
13
11
14
10
15
17
17
18
18
28
Part
No.
Page
No.
Ref.
No.
L99479
L99479
L99480
L99480
L99481
L99481
L99482
L99482
L99483
L99483
L99484
L99484
L99485
L99485
L99486
L99486
L99488
L99488
L99489
L99489
L99490
L99490
L99491
L99491
L99492
L99492
L99493
L99494
L99496
L99498
L99498
L99501
L99501
L99502
L99502
L99504
L99506
L99506
L99506
L99507
L99507
L99509
L99511
L99511
L99511
L99512
L99512
L99513
L99513
L99513
L99514
L99514
L99514
L99515
L99515
L99517
L99517
141
153
141
153
141
153
141
153
141
153
141
153
141
153
141
153
141
165
141
153
141
153
141
153
141
153
141
141
141
143
155
143
155
143
155
155
143
155
167
143
155
155
143
155
165
143
155
143
155
167
143
155
165
143
155
143
155
19
19
20
20
39
34
21
21
22
22
23
23
24
24
25
25
27
03
28
27
29
28
30
29
31
30
32
33
35
02
02
05
05
06
06
08
09
09
21
10
10
12
12
14
25
13
15
14
16
06
15
17
11
16
18
18
20
435
Part
No.
Page
No.
Ref.
No.
L99519
L99519
L99520
L99520
L99522
L99523
L99523
L99523
L99523
L99524
L99524
L99524
L99524
L99525
L99525
L99525
L99525
L99526
L99526
L99527
L99527
L99527
L99527
L99528
L99528
L99529
L99529
L99530
L99530
L99531
L99531
L99532
L99532
L99533
L99533
L99534
L99534
L99535
L99535
L99536
L99536
L99537
L99537
L99538
L99538
L99538
L99538
L99539
L99539
L99539
L99539
L99540
L99540
L99540
L99540
L99541
L99541
143
155
143
155
144
144
145
156
157
144
145
156
157
144
145
156
157
144
156
144
145
156
157
144
156
144
156
144
156
144
156
144
156
144
156
144
156
144
156
144
156
144
156
144
145
156
157
144
145
156
157
144
145
156
157
144
145
19
21
20
22
01
02
02
02
02
03
03
03
03
04
04
04
04
05
05
12
13
12
13
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
07
08
07
08
08
09
08
09
09
10
09
10
10
11
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L99541
L99541
L99542
L99542
L99542
L99542
L99543
L99543
L99544
L99544
L99545
L99545
L99546
L99546
L99547
L99547
L99547
L99548
L99548
L99549
L99549
L99550
L99550
L99551
L99551
L99552
L99552
L99553
L99553
L99554
L99554
L99555
L99555
L99555
L99555
L99556
L99556
L99556
L99556
L99557
L99557
L99557
L99557
L99558
L99558
L99558
L99558
L99560
L99560
L99561
L99561
L99561
L99561
L99561
L99564
L99565
L99566
156
157
144
145
156
157
146
158
146
158
146
158
146
158
146
158
170
146
158
146
158
146
158
146
158
146
158
147
159
147
159
147
147
159
159
147
147
159
159
147
147
159
159
147
147
159
159
147
159
147
147
159
159
167
149
149
149
10
11
11
12
11
12
01
01
02
02
03
03
04
04
05
05
11
06
06
07
07
08
08
09
09
10
10
01
01
02
02
03
03
03
03
04
04
04
04
05
05
05
05
06
06
06
06
08
08
09
09
09
09
25
03
04
05
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L99567
L99568
L99574
L99575
L99576
L99577
L99579
L99581
L99584
L99584
L99584
L99585
L99585
L99586
L99586
L99586
L99587
L99587
L99588
L99588
L99589
L99590
L99590
L99592
L99592
L99593
L99593
L99593
L99593
L99596
L99596
L99597
L99597
L99598
L99598
L99599
L99599
L99600
L99600
L99601
L99601
L99602
L99602
L99603
L99603
L99604
L99604
L99606
L99610
L99610
L99612
L99613
L99613
L99614
L99614
L99615
L99615
149
149
149
149
149
149
149
149
150
160
172
150
160
150
160
172
150
160
150
160
160
150
160
150
160
143
150
155
160
150
160
151
161
151
161
151
161
151
161
151
161
151
161
151
161
151
161
153
155
167
145
145
157
145
157
141
151
06
07
08
09
10
11
13
15
01
01
05
02
02
03
03
06
04
04
05
05
06
07
07
08
08
21
09
23
09
10
10
01
01
02
02
03
03
04
04
05
05
06
06
07
07
08
08
28
11
26
01
05
05
06
06
26
09
Part
No.
Page
No.
Ref.
No.
L99615
L99615
L99615
L99615
L99617
L99617
L99618
L99618
L99619
L99619
L99620
L99620
L99621
L99621
L99622
L99622
L99623
L99623
L99624
L99624
L99625
L99625
L99626
L99626
L99628
L99628
L99629
L99629
L99630
L99630
L99631
L99631
L99632
L99632
L99633
L99633
L99634
L99634
L99635
L99635
L99636
L99636
L99637
L99637
L99641
L99642
L99643
L99649
L99661
L99662
L99663
L99664
L99665
L99666
L99667
L99668
L99669
153
161
165
172
145
157
145
157
145
157
145
157
145
157
145
157
145
157
145
157
145
157
145
157
146
158
146
158
146
158
146
158
146
158
146
158
146
158
146
158
147
159
147
159
153
153
156
157
117
117
117
117
117
117
117
117
117
26
09
02
12
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
06
07
07
01
01
02
02
03
03
04
04
08
08
09
09
10
10
11
11
01
01
02
02
03
16
01
01
01
02
03
04
05
06
07
08
09
436
Part
No.
Page
No.
Ref.
No.
L99670
L99670
L99671
L99671
L99672
L99672
L99673
L99673
L99674
L99675
L99676
L99677
L99678
L99679
L99679
L99680
L99681
L99682
L99683
L99684
L99685
L99685
L99686
L99687
L99688
L99689
L99690
L99691
L99693
L99694
L99695
L99696
L99696
L99697
L99698
L99702
L99703
L99704
L99705
L99706
L99707
L99708
L99708
L99708
L99708
L99708
L99708
L99708
L99708
L99708
L99709
L99709
L99709
L99709
L99709
L99709
L99709
117
118
117
118
117
118
117
118
117
117
117
117
117
117
117
117
117
117
117
117
117
118
118
118
118
118
118
118
119
121
121
121
132
121
121
120
120
120
120
120
123
123
123
125
125
127
127
129
129
131
123
123
125
125
127
129
129
10
07
11
08
14
03
15
04
16
17
18
20
21
23
29
31
26
27
30
38
39
13
01
05
06
12
14
19
02
01
02
04
05
05
06
01
02
03
04
05
01
02
17
02
16
02
17
02
16
02
05
20
05
19
05
05
19
PRINTED IN U.S.A.
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L99709
L99710
L99710
L99710
L99710
L99710
L99710
L99710
L99711
L99711
L99711
L99711
L99711
L99711
L99711
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99712
L99713
L99713
L99713
L99713
L99713
L99713
L99713
L99713
L99713
L99714
L99714
L99714
L99714
L99714
L99714
L99714
L99714
L99714
L99715
L99715
L99716
L99716
L99717
L99717
131
123
123
125
125
127
129
131
123
123
125
125
127
129
131
123
123
123
123
125
125
125
125
127
127
127
127
129
129
129
129
131
131
123
123
125
125
127
127
129
129
131
123
123
125
125
127
127
129
129
131
123
127
123
127
123
127
05
06
21
06
20
06
06
06
07
22
07
21
07
07
07
09
12
24
27
09
12
23
26
09
12
23
26
09
12
22
25
09
12
10
25
10
24
10
24
10
23
10
11
26
11
25
11
25
11
24
11
13
13
15
15
16
16
PRINTED IN U.S.A.
Numerical Index
Part
No.
Page
No.
Ref.
No.
L99718
L99718
L99718
L99718
L99718
L99719
L99719
L99720
L99720
L99721
L99721
L99721
L99721
L99722
L99722
L99722
L99722
L99723
L99723
L99724
L99724
L99724
L99724
L99725
L99725
L99725
L99725
L99726
L99726
L99726
L99726
L99727
L99727
L99727
L99727
L99728
L99728
L99729
L99729
L99730
L99730
L99730
L99730
L99730
L99730
L99730
L99731
L99732
L99733
L99733
L99733
L99734
L99734
L99735
L99735
L99736
L99736
123
125
127
129
131
123
127
123
127
123
125
127
129
123
125
127
129
123
125
123
125
127
129
123
123
125
125
123
123
125
125
123
123
125
125
123
125
123
125
123
125
127
129
131
132
132
127
127
127
129
131
127
129
127
129
127
129
28
27
28
27
14
31
31
32
32
33
31
33
31
35
33
35
33
37
35
38
36
38
36
39
45
37
43
40
44
38
42
41
43
39
41
42
40
46
44
47
45
45
43
22
07
11
01
20
27
26
13
37
35
39
37
40
38
Part
No.
Page
No.
Ref.
No.
L99736
L99737
L99737
L99737
L99738
L99738
L99738
L99739
L99739
L99740
L99740
L99740
L99741
L99742
L99743
L99744
L99745
L99746
L99747
L99748
L99749
L99750
L99751
L99752
L99752
L99753
L99753
L99754
L99755
L99756
L99756
L99757
L99758
L99759
L99760
L99761
L99762
L99763
L99764
L99764
L99765
L99766
L99767
L99768
L99769
L99769
L99769
L99770
L99771
L99772
L99773
L99774
L99775
L99776
L99778
L99778
L99779
131
127
129
131
127
129
131
127
129
127
131
132
132
132
132
132
131
131
131
131
131
131
131
131
133
131
133
133
133
133
133
133
133
133
133
133
133
133
135
137
135
135
135
135
137
137
137
137
137
137
137
137
137
137
137
137
137
17
41
39
18
42
40
19
43
41
44
21
10
01
02
03
09
01
16
20
23
24
25
26
27
12
28
13
01
02
03
05
04
06
08
09
10
11
07
01
00
02
03
04
05
28
39
48
29
30
32
33
35
36
37
42
42
43
437
Part
No.
Page
No.
Ref.
No.
L99780
L99781
L99782
L99784
L99785
L99786
L99787
L99787
L99796
L99797
L99798
L99799
L99799
L99800
L99800
L99801
L99802
L99803
L99804
L99805
L99807
L99808
L99809
L99810
L99811
L99812
L99813
L99814
L99815
L99816
L99817
L99818
L99819
L99820
L99821
L99822
L99823
L99823
L99824
L99825
L99825
L99826
L99827
L99828
L99829
L99831
L99834
L99843
L99843
L99843
L99843
L99844
L99844
L99844
L99845
L99845
L99845
137
137
137
134
134
118
127
129
111
111
111
109
111
109
111
113
113
113
113
113
113
113
111
111
111
111
111
111
113
113
113
111
111
113
113
113
111
113
113
109
113
113
113
111
111
343
137
23
23
53
57
49
53
57
49
53
57
45
46
47
01
05
02
21
20
22
03
11
05
24
06
02
05
13
19
14
02
04
12
07
08
09
14
15
16
18
06
01
06
21
09
10
17
10
16
11
04
20
07
08
01
01
14
40
04
07
36
30
29
37
31
29
37
31
907878/DP0208
Numerical Index
Part
No.
Page
No.
Ref.
No.
L99847
L99847
L99847
L99847
L99848
L99849
L99851
L99852
L99853
L99854
L99856
L99857
L99857
L99857
L99859
L99860
L99861
L99862
L99863
L99864
L99865
L99866
L99868
L99869
L99870
L99871
L99872
L99873
L99874
L99875
L99877
L99878
L99879
L99879
L99880
L99881
L99882
L99883
L99885
L99886
L99887
L99888
L99889
L99890
L99891
L99891
L99892
L99893
L99894
L99895
L99896
L99897
L99898
L99899
L99900
L99903
L99903
53
55
57
59
29
367
367
371
367
367
367
363
367
369
367
367
367
367
367
369
369
369
369
369
369
369
369
373
373
373
373
373
371
373
373
373
373
371
371
371
371
371
371
371
307
371
343
343
343
343
343
343
343
343
85
271
341
38
00
32
29
17
11
06
06
02
05
04
08
08
06
11
06
02
05
04
07
02
05
11
11
07
02
04
12
10
09
08
04
04
06
04
04
04
13
07
02
03
05
01
03
29
01
08
10
13
01
02
03
06
15
10
22
10
907878/DP0208
DL Series Dynalift
Part
No.
Page
No.
Ref.
No.
L99903
L99904
L99905
L99905
L99907
L99908
L99908
L99908
L99908
L99908
L99908
L99908
L99909
L99910
L99910
L99910
L99910
L99911
L99911
L99911
L99911
L99911
L99911
L99911
L99912
L99912
L99913
L99914
L99916
L99917
L99917
L99917
L99917
L99917
L99919
L99920
L99921
L99922
L99923
L99924
L99925
L99925
L99925
L99927
L99927
L99928
L99929
L99930
L99931
L99931
L99931
L99932
L99932
L99932
L99933
L99933
L99933
343
343
343
345
339
335
336
337
339
346
347
352
346
335
336
346
347
335
336
337
346
346
347
347
337
353
361
361
361
339
347
367
371
377
337
339
339
339
339
347
334
337
339
247
334
334
334
267
101
103
105
101
103
105
101
103
105
12
00
16
07
00
03
03
04
03
03
05
02
02
02
02
01
04
02
02
00
01
02
01
04
02
03
04
05
04
05
02
12
12
08
03
04
01
07
06
03
02
03
04
07
02
01
01
01
16
23
13
17
24
12
16
23
13
Part
No.
Page
No.
Ref.
No.
L99934
L99935
L99936
L99937
L99938
L99941
L99942
L99943
L99943
L99944
L99951
L99951
L99961
L99962
L99963
L99964
L99965
L99966
L99966
L99966
L99966
L99966
L99967
L99967
L99967
L99967
L99970
L99970
L99970
L99971
L99972
L99972
L99974
L99979
L99982
L99983
L99983
L99983
L99983
L99983
L99987
L99988
L99989
L99991
L99992
L99995
L99995
L99996
L99998
P054800
P272700
P272700
P471299
P471353
P471353
P471356
P471356
365
365
365
365
365
361
365
373
375
379
139
163
359
359
359
359
359
53
55
57
59
93
9
101
103
105
87
87
297
99
95
99
21
93
93
49
53
55
57
59
377
377
377
377
377
143
155
149
352
65
229
321
305
87
297
311
313
02
08
04
03
05
05
09
03
09
07
02
02
02
03
04
05
06
39
00
33
30
31
06
14
21
15
19
32
12
01
15
01
10
17
20
29
37
00
31
27
09
11
01
04
05
22
24
17
03
05
11
07
02
30
18
28
25
438
Part
No.
Page
No.
Ref.
No.
P47159
P471997
P471997
247
247
249
26
12
13
PRINTED IN U.S.A.
Torque Specifications
Use these torque values when tightening hardware (excluding: locknuts and self-tapping, thread-forming and metal screws)
unless otherwise specified.
Grade 5
Grade 8
Unified National
Thread
Grade 2
Dry
Lubed
Dry
Lubed
8-32
8-36
10-24
10-32
1/4-20
1/4-28
5/16-18
5/16-24
3/8-16
3/8-24
7/16-14
7/16-20
1/2-13
1/2-20
9/16-12
9/16-18
5/8-11
5/8-18
3/4-10
3/4-16
7/8-9
7/8-14
1-8
1-14
19*
20*
27*
31*
66*
76*
11
12
20
23
32
36
35
40
55
60
75
85
130
150
125
140
190
210
14*
15*
21*
23*
50*
56*
9
9
15
17
24
27
35
40
55
60
75
85
130
150
125
140
190
210
30*
31*
43*
49*
9
10
17
19
30
35
50
55
75
90
110
120
150
180
260
300
430
470
640
710
22*
23*
32*
36*
75*
86*
13
14
23
25
35
40
55
65
80
90
110
130
200
220
320
360
480
530
Metric Course
Thread
Grade 8.8
M6-1
24M8-1.25
M10-1.5
M12-1.75
M14-2
M16-2
8
19
37.5
65
103.5
158.5
Dry
Grade 10.9
Lubed
Dry
6
14
28
48
76.5
117.5
11
27
53
91.5
145.5
223.5
Dry
Lubed
41*
43*
60*
68*
12
14
25
25
45
50
70
80
110
120
150
170
220
240
380
420
600
660
900
1000
31*
32*
45*
51*
9
10
18
20
35
35
55
60
80
90
110
130
170
180
280
320
460
500
680
740
Grade 12.9
Lubed
Dry
Lubed
7
20
39
67.5
108
165.5
13.5
32.5
64
111.5
176.5
271
10*
24*
47
82
131
200
* All torque values are in lb.-ft. except those marked with an *, which are in lb.-in.
For metric torque value (Nm), multiply lb.-ft. value by 1.355 or lb.-in. by 0.113.
PRINTED IN U.S.A.
439
907878/DP0208
GEHL Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A
www.gehl.com
907878/DP0208
©2008 Gehl Company, All Rights Reserved.
PRINTED IN U.S.A.

DL6 DL8 DL10 DL12 Dynalift Parts Manuals - German

Transcription

Similar documents

DL Series P arts Manual

RS6-42 RS8-42/44 RS10-44/55 RS12-42 Parts

883 - Hawkins Equipment

Telescopic Handler - Hawkins Equipment