MSDS Material Safety Data Sheet Bar’s Products Rislone®

Material Safety Data Sheet
MSDS
Section 1 – CHEMICAL PRODUCT AND COMPANY INFORMATION
Product Brand:
Product Part #:
Rislone®
100-QR, 100-5R, 100-50R
Rislone Engine Treatment
1-800-424-9300
Product Name:
Bar’s Products
720 West Rose Street
P.O. Box 187
Holly, Michigan 48442
24-Hour Emergency
(CHEMTREC)
Information:
1-248-634-8278 / rislone.com
5-11-06
Date Prepared:
Section 2—COMPOSITION / INFORMATION ON INGREDIENTS
Hazardous Components (Specific Chemical Identity, Common
Name(s))
CAS NUMBER
OSHA
PEL
ACGIH
TLV
Other
Limits
%
(optional)
80-85
<10
5
5mg/m³
5mg/m³
64742-65-0
5mg/m³
5mg/m³
N/A Mixture
Olefin Copolymer-Viscosity Improver
5mg/m³
5mg/m³
N/A Mixture
Upper Cylinder Treatment Additive
N/A
N/A
123-86-4
All other components are considered to be non-hazardous as per OSHA 29 CFR 1910.1200.
Severely Hydrotreated Petroleum Oil
Additive Mixture Containing Compounds of Ca, Zn, S, P, N, Mg, Na
Section 3—HAZARDS IDENTIFICATION
Potential Health Effects:
EYE -
No irritation is expected from short-term exposure.
Mild skin irritation may occur upon short-term exposure
INHALATION Exposure to mist or vapor at high levels may be irritating to the nose, throat
and lungs, and may cause nausea, vomiting, and drowsiness.
INGESTION No significant adverse health effects are expected to occur under normal
conditions of use. However, exposure to petroleum mist at high levels may be
irritating to the nose, throat and lungs.
Mild skin irritation and inflammation following extended use.
None expected on industrial level.
Disorders or disease of the skin, or respiratory system.
SKIN -
Acute Health Hazards:
Chronic Health Hazards:
Medical Conditions
Aggravated by Exposure:
Target Organ Effects:
No data available
OSHA
No
Carcinogenicity:
IARC
No
NTP
No
Section 4—FIRST AID MEASURES
Eye:
Flush eyes with low pressure water for 15 minutes.
Wash skin thoroughly with soap and water.
Remove victim to fresh air and get medical attention.
Do not induce vomiting. Give several glasses of water. Get medical attention.
Treat for clinical symptoms.
Skin Contact:
Inhalation:
Ingestion:
Note To Physician:
Section 5—FIRE FIGHTING MEASURES
Flash Point (Method Used):
Flammable
Limits
LEL (lower explosion limit):
UEL (upper explosion limit):
Extinguishing Media:
Special Fire Fighting Procedures:
Unusual Fire and Explosion Hazards:
NFPA National Fire Protection Agency:
HMIS Hazardous Material Identification:
160 ºC (320 ºF) / COC D92
N/A
N/A
Dry chemical and carbon dioxide.
Slightly combustible – Use proper protective equipment
None known
Health 1
Flammability
1
Reactivity
0
Health 1
Flammability
1
Reactivity
0
PPE
B
Section 6—ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedures:
Dike or pillow area to contain spill.
Section 7—HANDLING AND STORAGE
Storage Temperature (MIN/MAX):
Handling/Storage Precautions:
Shelf Life:
Ambient
N/E
Store in original container in area inaccessible to children and pets. Do not reuse.
1
Section 8—EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Controls:
Respiratory Protection:
Skin Protection:
Eye Protection:
Adequate ventilation
None required in normal use. Over exposure requires approved respiratory equipment.
Rubber gloves and full work clothing to minimize exposure.
Safety glasses.
Section 9—PHYSICAL / CHEMICAL PROPERTIES
Physical State:
Appearance:
Odor:
Solubility in Water:
2
Specific Gravity (H 0 = 1):
pH:
Percent Volatiles (VOC):
Liquid
Blue – Blue Green
Slight petroleum
Negligible
0.90-0.92
Freezing Point:
Vapor Density (AIR = 1):
N/D
N/A
GT 600 ºF
N/A
N/D
N/A
Negligible
Vapor Pressure (mm Hg):
Low
Melting Point:
Boiling Point °F (°C):
Evaporation Rate:
Section 10—STABILITY AND REACTIVITY
Chemical Stability:
Incompatibility:
Hazardous Decomposition Products:
Hazardous Polymerization:
Conditions to Avoid:
Stable
Strong acids, alkalis and oxidizers.
Carbon Monoxide, calcium, zinc, sulfur, phosphorous, sodium, nitrogen and
magnesium.
Will not occur
Strong acids, alkalis and oxidizers.
Section 11—TOXICOLOGICAL INFORMATION
No Significant adverse health effects are expected upon short-term exposure.
Section 12—ECOLOGICAL INFORMATION
Ecotoxicological Information:
Environmental Fate:
Maybe hazardous to animal/aquatic life
No data available.
Section 13—DISPOSAL CONSIDERATIONS
Use approved treatment, transporters and disposal sites as defined by state/federal laws
Section 14—TRANSPORTATION INFORMATION
U.S. Proper Shipping Name:
DOT (Domestic Surface) Hazard Class or Division:
IMO / IMDG (Ocean) Hazard Class Division Number:
ICAO / IATA (Air) Hazard Class Division Number:
Not a DOT “Hazardous material”
Not regulated
Not regulated
Not regulated
Section 15—REGULATORY INFORMATION
SARA Title III Section 302 Extremely Hazardous Substances:
SARA Title III Section 311/312 Hazard Categories:
SARA Title III Section 313 Toxic Chemicals:
OSHA Status:
TSCA Status:
CIRCLA Reportable Quantity:
None
Immediate and delayed health hazards
None
Not regulated
Chemical components listed on TSCA inventory.
N/A
Section 16—OTHER INFORMATION
N/A
N/D
Not Applicable
Not Determined
N/E
Last Page
2
Not Established