552/553 Dynalift - Hawkins Equipment

Transcription

552/553
Dynalift
®
Telescopic
Boom Forklift
PARTS MANUAL
Form No.
908459
Introduction
552/553 Dynalift
The table of contents pages show the page location
of various component groups on the machine.
When ordering service parts, specify the correct part
number, full description, quantity required, and the
unit model and serial number.
Model and serial numbers for this unit are stamped
on a plate located inside the operator’s station. The
serial number is also stamped on the top front frame.
The following reference shows the breakdown of
the serial number:
Model
Unit Number
Engine
NOTE: On original tire replacement, Company
policy prohibits the sale of replacement tires for all
Gehl machinery. Replacement wheel sets are
available and tire size information is called out
with the wheel sets to facilitate replacement tire
selection. ALL REPLACEMENT TIRES MUST BE
PURCHASED LOCALLY.
Grease fittings and common attaching hardware, such
as cotter pins, set screws, woodruff keys, screws, nuts,
etc., are included in the parts list, indented below the
part it is (they are) associated with, but may NOT be
illustrated, except where a particular routing or special
fastening arrangement MUST be maintained. The
hardware listed is for mounting purposes and is NOT
included when the part is ordered for replacement.
Part numbers for standard hardware are listed indented
under the component being fastened.
553 J U 01 3822
Month
Year (U=03, V=04, W=05, etc.)
“Right” and “left” are determined from a position sitting on the seat and facing forward.
Gehl Company reserves the right to make changes or
improvements in the design or construction of any part
of the unit without incurring the obligation to install
such changes on any unit previously delivered.
A complete listing of part numbers for attaching washers/nuts used on this machine is included in the table
on the facing page. Refer to the abbreviations list on
the facing page for descriptions.
Standard attaching hardware torque values are provided on the inside back cover. Unless otherwise specified, all cap screws are Grade 5, cadmium or zinc plated; hexagon nuts for Grade 5 cap screws or bolts are
Grade A.
552/553 Dynalift
Introduction
List of Abbreviations Used in this Manual
AN
AR
ASY
BHB
CB
CN
CYL
CS
DIA
FHMS
FLN
FLS
FT
GR
HLN
HYD
JN
L
LH
LT
N
NIN
NPTF
P
PB
PHS
RH
RHMS
RHSMS
RNF
RT
SHCS
SHSS
SFN
SHSS
STS
THMS
TRS
W/
WN
FILTER REFERENCE
TYPE
Engine Oil
Acorn Nut
As Required
Assembly
Button Head Bolt
Carriage Bolt
Castellated Nut
Cylinder
Cap Screw (Hexagon Head)
Diameter
Flat Head Machine
Flanged Flexlock Nut
Flanged Lock Screw
Foot or Feet
Grade
Hexlock Nut
Hydraulic
Jam Nut
Lock (Washer)
Left Hand
Left
Nut (Plain Hex)
Nylon Insert Lock Nut
National Pipe Threaded Fitting
Plain (Washer)
Plow Bolt
Pan Head Screw
Right Hand
Round Head Machine Screw
Round Head Sheet Metal Screw
Retained Nut Fastener
Right
Socket Head Cap Screw
Socket Head Set Screw
Serrated Flange Nut
Square Head Set Screw
Self-Thread Screw Hex. Washer Head
Truss-Head Machine Screw
Thread Roll Screw
With
Wing Nut
552; w/JD Engine S/N 1021 & Up . . . . . . . . . . .
553; w/JD Nat.Eng. S/N 3917 & Up
553; w/JD Turbo Eng S/N 3630 & Up
L99420
552; w/JD Engine Thru S/N 1020. . . . . . . . . . . .
553; w/JD Nat. Eng Thru S/N 3916
553; w/JD Turbo Eng Thru S/N 3629
L99476
With Perkins Engine. . . . . . . . . . . . . . . . . . . . . . L98601
Engine Fuel
552; w/JD Engine S/N 1011 & Up . . . . . . . . . . .
553; w/JD Engine S/N 3127 & Up
L99978
552; w/JD Engine Thru S/N 1010. . . . . . . . . . . .
553; w/JD Engine Thru S/N 3126
L98600
With Perkins Engine . . . . . . . . . . . . . . . . . . . . . L98602
Engine Air
. . . . . . . . . . . . . . . . . . . L120054
Transmission Oil . . . . . . . . . . . . . . . . . . . . L99184
Hydraulic Oil . . . . . . . . . . . . . . . . . . . . . L97489
TABLE OF STANDARD WASHERS, NUTS
Size &
Description
Part No.
Size &
Description
Part No.
#10-32 N
L50050
1/4 L
1/4-20 NIN
1/4 P
1/4-20 SFN
L50139
L520003
L50137
L50051
7/16 L
7/16-14 NIN
7/16 P
L50150
L50517
L50149
1/2-13 NIN
1/2 P
L520019
L50151
5/16 L
5/16-18
5/16-18
5/16 P
5/16-18
5/16-18
L50143
L50230
L520004
L50141
L530004
L50056
5/8 L
5/8-11 N
L50156
L50081
3/4-10 N
3/4-10 NIN
3/4 P
L50086
L50519
L50147
L50147
L50066
L520005
L50145
L50061
L530003
1-8 JN
L50145
3/8-16
3/8-16
3/8-16
3/8-16
3/8-16
3/8-16
PRINTED IN U.S.A.
PART NUMBER
1
N
NIN
RNF
SFN
L
N
NIN
P
SFN
WN
908459/AP0603
Table of Contents
552/553 Dynalift
Page
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Inside Front Cover
List of Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Filter Reference Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
DECALS
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
New Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Decal Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
OPERATOR STATION
Safety Guards, Windows and Cab . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Front and Rear Windows (552: S/N 1015 and Up ; 553: S/N 3368 and Up) . . . . . . . . . . . . . . . . . . .14
Front and Rear Windows (552: Thru S/N 1014; 553: Thru S/N 3367) . . . . . . . . . . . . . . . . . . . . . . .16
Windshield Wipers / Top and Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Side Door and Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20
Cab Mounts and Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22
Steering Column Group (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . . . . . . .24
Steering Column Group (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . . . . . . . .26
Seat Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Top Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Under Dash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32
Accelerator and Brake Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34
Heater (No Air Conditioning) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36
Air Conditioning Group (w/Heater) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38
CHASSIS
Frame Hoods and Covers (552: S/N 1015 and Up; 553: S/N 3340 and Up) . . . . . . . . . . . . . . . . . . .40
Frame Hoods and Covers (552: Thru S/N 1014; 553: Thru S/N 3339) . . . . . . . . . . . . . . . . . . . . . . .42
Hydraulic and Fuel Tanks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44
Battery Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48
ENGINE
External Engine Components Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50
Radiator and Cooler Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52
Engine Air Intake Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54
Engine Exhaust Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56
TRANSMISSION
External Transmission and Drive Shaft Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58
Internal Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60
908459/AP0603
2
PRINTED IN U.S.A.
552/553 Dynalift
Table of Contents
Page
AXLES
External Components Group (552: S/N 1075 and Up; 553: S/N 4832 and Up) . . . . . . . . . . . . . . . . .62
External Components Group (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . . . . . . . . .64
Outer End Group (552: S/N 1075 and Up; 553: S/N 4832 and Up) . . . . . . . . . . . . . . . . . . . . . . . . .66
Outer End Group - Part I (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . . . . . . . . . . .68
Outer End Group - Part II (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . . . . . . . . . .70
Differential Housing Group (552: S/N 1075 and Up; 553: S/N 4832 and Up) . . . . . . . . . . . . . . . . .72
Differential Group (552: S/N 1075 and Up; 553: S/N 4832 and Up) . . . . . . . . . . . . . . . . . . . . . . . .74
Differential Housing Group - Part I (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . . .76
Differential Housing Group - Part II (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . .78
Differential Housing Group - Part III (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . .80
Brake Group (552: S/N 1075 and Up; 553: S/N 4832 and Up) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82
Brake Group (552: Thru S/N 1074; 553: Thru S/N 4831) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84
BOOM
552-Outer Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86
552-Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88
553-Outer Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90
553-Intermediate Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92
553-Inner Boom Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94
Dynattach . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96
HYDRAULIC SYSTEMS
Hydraulic Pump, Tank and Flow Divider (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . .98
Hydraulic Pump, Tank and Priority (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . .100
Steer Motor and Steer Select Valve (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . .102
Steer Motor and Steer Select Valve (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . .104
Main Valve Group (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . . . . . . . . . .106
Main Valve Group (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . . . . . . . . . . .108
Joystick Group (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . . . . . . . . . . . . .110
Joystick Group (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .112
Frame Level Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Lift Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .116
Tilt / Slave Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118
Boom Extend Cylinder Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120
Auxilary Hydraulics Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .122
HYDRAULIC COMPONENTS
Hydraulic Pump Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124
Flow Divider Breakdown (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . . . . .125
Main Valve Hyd. Breakdown (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . .126
Main Valve Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . . . . . . .128
Priority Valve/Flow Divider Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . .129
(Continued on next page)
PRINTED IN U.S.A.
3
908459/AP0603
Table of Contents
552/553 Dynalift
Page
HYDRAULIC COMPONENTS (CONTINUED)
Frame Level Valve Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . .130
Auxilary Hydraulics Work Section Breakdown (552: S/N 1057 and Up; 553: S/N 4519 and Up) . .126
Auxilary Hydraulics Valve Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . .131
Steer Cylinders Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .132
Steer Valve Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133
Steer Motor Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .134
Brake Valve Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .135
Joystick Breakdown (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . . . . . . . . . . . . . . . . .136
Auxilary Hydraulic Joystick Breakdown (552: S/N 1057 and Up; 553: S/N 4519 and Up) . . . . . . .138
Joystick Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . . . . . . . . . . . . . . . . . .140
Auxilary Hydraulic Joystick Breakdown (552: Thru S/N 1056; 553: Thru S/N 4518) . . . . . . . . . .142
Dual Relief Valve Breakdown (552: S/N 1042 and Up; 553: S/N 4207 and Up) . . . . . . . . . . . . . . .144
Dual Relief Valve Breakdown (552: Thru S/N 1041; 553: Thru S/N 4206) . . . . . . . . . . . . . . . . . . .145
Frame Level Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .146
Lift Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .148
Slave Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .150
Tilt Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152
Boom Extend Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .154
Fork Shift Carriage Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .156
Rotate Carriage Cylinder Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .157
ATTACHMENTS
Standard Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .158
Shift Fork Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .160
Rotate Carriage Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .162
Boom Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .164
Bucket Attachment Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .166
NUMERICAL INDEX
Numerical Index List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .168
908459/AP0603
4
PRINTED IN U.S.A.
552/553 Dynalift
PRINTED IN U.S.A.
Notes
5
908459/AP0603
Decals
552/553 Dynalift
Then, properly orient and position the decal onto the
clean mounting surface. After the decal is firmly
applied and smoothly pressed down, remove the front
covering paper.
CAUTION
ALWAYS read and follow the safety precautions on decals. Replace decals if they are
damaged, or if the unit is repainted. If repainting, BE SURE that all applicable decals are
affixed in their proper locations.
PAINT FINISH
Use this list to order paint for refinishing:
552: Thru S/N 1007; 553: Thru S/N 3062:
903891
906317
GENERAL INFORMATION
552: S/N 1008 & Up; 553: S/N 3063 & Up:
Decal Locations information is provided to assist in the
proper selection and application of new decals, in the
event the original decal(s) become(s) damaged or the
machine is repainted.
906213
906317
906323
906214
906318
For correct replacement of decal(s) compare the location illustrations to your machine before starting to
refinish the unit. Check-off each required decal using
the illustration reference number to find the part number, description and quantity in the list. Refer to the
appropriate illustration(s) for replacement location(s).
One Gal. Yellow
One Gal. Charcoal Grey
One Qt. Charcoal Grey
6 (12 oz. Spray Cans) Yellow
6 (12 oz. Spray Cans) Charcoal Grey
Decal Kits
L98556
L98863
L98557
L98864
NEW DECAL APPLICATION
thru S/N 1007 Model 552
S/N 1008 & up Model 552
thru S/N 3062 Model 553
S/N 3063 & up Model 553
NOTE: Decals may be purchased in kits or
Before applying the new decals, surfaces must be free
from dirt, dust, grease and other foreign material. To
apply a solid-formed decal, remove the smaller portion
of the decal backing paper and apply this part of the
exposed adhesive backing to the clean surface while
maintaining proper position and alignment. Slowly
peel off the other portion of the backing paper while
applying hand pressure to smooth-out decal surface. To
apply a die-cut decal, first remove the backing paper.
908459/AP0603
6-12 oz Industrial Yellow
6-12 oz Black
individually.
6
PRINTED IN U.S.A.
552/553 Dynalift
Decals
3
9
5
11
4
7
6
1
10
4
8
2
12
4
DECAL LOCATIONS - RIGHT SIDE OF MACHINE
REF.
NO.
DESCRIPTION
552
553
01
02
03
03
04
05
DANGER - ROTATING FAN
DYNALIFT
552
553
WARNING - PINCH POINT
GEHL 6.38”
L65924
L66568
L66585
--L65927
122288
L65924
L66568
--L66581
L65927
122288
06
07
08
09
10
11
12
DYNATTACH 1-1/2”
WARNING - HOT SURFACE
WARNING - NO RIDERS
GEHL 2”
DYNATTACH UNLOCK RED STRIPE
DANGER - PERSONNEL
GREASE DAILY
L66569
L65942
L65932
L66584
L66613
L65928
L65920
L66569
L65942
L65932
L66584
L66613
L65928
L65920
PRINTED IN U.S.A.
7
908459/AP0603
Decals
552/553 Dynalift
8
1
4
6
2
7
3
10
5
9
DECAL LOCATIONS - LEFT SIDE OF MACHINE
REF.
NO.
DESCRIPTION
552
553
01
02
03
04
04
DANGER - ROTATING FAN
GEHL 4.5”
DYNALIFT
552
553
L99863
L66565
L66568
L66585
---
L98864
L66565
L66568
--L66581
05
06
07
08
09
10
WARNING - NO RIDERS
WARNING - JUMP START
GEHL 6.38”
BRAKE FLUID LEVEL
OPERATOR MANUAL INSIDE
L65927
122288
L65933
L65932
L63474
L65922
L65927
122288
L65933
L65932
L63474
L65922
908459/AP0603
8
PRINTED IN U.S.A.
552/553 Dynalift
Decals
9
1
2
3
8
1
2
5
10
11
5
6
7
4
DECAL LOCATIONS
REF.
NO.
DESCRIPTION
552
553
L62583
(5 ea.)
L67718
L67719
L67720
01
HALF ZONE EXTENSION MARKER
02
02
02
NO. “0” EXTENSION MARKER
L62583
(3 ea.)
--L67719
L67720
02
02
02
03
04
GREASE DAILY
DYANTTACH DIAGRAM
------L65920
L65937
L67721
L67722
L67723
L65920
L65937
05
06
07
08
09
10
11
WARNING - CARRY LOAD LOW
DYNATTACH - 1 1/2”
COOLANT UNDER PRESSURE
ANTI-FREEZE NOTE
DIESEL FUEL
HYDRAULIC OIL
L65927
L65926
L66569
072798
056859
072797
072794
L65927
L65926
L66569
072798
056859
072797
072794
PRINTED IN U.S.A.
9
908459/AP0603
Decals
552/553 Dynalift
9
3
2
7
8
6
4
10
5
1
DECAL LOCATIONS - DETAILS IN OPERATOR STATION
REF.
NO.
DESCRIPTION
552
553
01
02
03
04
05
GEHL 2.0” DIA.
WARNING - SEAT BELT
STEER SELECTOR
F-N-R CONTROL
IGNITION/HORN (w/o Pushbutton Start)
L65224
L65440
L63618
L68295
L68052
L65224
L65440
L63618
L68295
L68052
05
05
06
07
08
IGNITION/HORN (Perkins Engine only)
IGNITION/HORN (w/ Pushbutton Start)
MADE IN USA
WARNING - PARK BRAKE
WARNING - OPERATOR
L63692
L68513
094951
L65925
L63690
L63692
L68513
094951
L65925
L63690
09
10
10
10
10
WARNING CARRY LOAD LOW
LOADCHART-ROTATING CARRIAGE
LOADCHART-TRUSS BOOM
LOADCHART-STANDARD CARRIAGE
LOADCHART-BUCKET
093475
L63437
L63454
L63661
L63926
093475
---------
908459/AP0603
10
PRINTED IN U.S.A.
552/553 Dynalift
Decals
12
10
13
3
1
8
2
9
11
5
6
7
4
DECAL LOCATIONS - DETAILS IN OPERATOR STATION
REF.
NO.
DESCRIPTION
552
553
01
02
03
04
05
DANGER - PERSONNEL
WARNING - TRUSS BOOM
WARNING - MACHINE LEVEL
MAINTENANCE CHART
TILT/LEVEL CONTROL
L65928
L66042
L65930
L63542
L63632
L65928
L66042
L65930
L63542
L63632
06
07
08
09
10
BOOM CONTROL
FILTER CHART
DANGER - PANEL IN PLACE
DANGER - POWER LINES
BRAKE FLUID LEVEL
L63631
L68084
L65948
L65929
L63474
L63631
L68084
L65948
L65929
L63474
11
12
13
13
13
OPERATOR MANUAL INSIDE
LOADCHART-STANDARD CARRIAGE
LOADCHART-ROTATING CARRIAGE
LOADCHART-TRUSS BOOM
L65922
L65927
-------
L65922
L65927
L68671
L68672
L68673
13
13
LOADCHART-BUCKET
LOADCHART-WINCH
-----
L68674
L68675
PRINTED IN U.S.A.
11
908459/AP0603
Operator’s Station
552/553 Dynalift
Safety Guards and Windows
5
4
1
6
2
7
8
3
9
11
10
908459/AP0603
12
PRINTED IN U.S.A.
552/553 Dynalift
Safety Guards and Windows
Ref.
No.
Part
No.
01
02a
02b
03
04
05
06
07
08
L67282
L63739
L99137
L63529
L63530
L63531
L63532
L63896
L520019
L50286
L63725
L50367
L50147
L63737
L71393
L71392
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
09
GLASS, RIGHT SIDE . . . . . . . . . . . 1
See note a
See note b
GASKET, SINGLE (12.5’) . . . . . . . . 1
GLASS PRIMER . . . . . . . . . . . . . AR
GLASS PRIMER . . . . . . . . . . . . . AR
METAL PRIMER . . . . . . . . . . . . . AR
GLASS ADHESIVE . . . . . . . . . . . AR
APPLICATION INSTR. . . . . . . . . . . 1
1/2”-13 NYLON INSERT NUT. . . . . 2
1/2”-13X1-3/4” BOLT . . . . . . . . . . . 2
OVERHEAD GUARD, WLDMNT . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . 4
3/8” LOCK WASHER . . . . . . . . . . . 4
GLASS, TOP . . . . . . . . . . . . . . . . . 1
PRIMER, GLASS ADHESIVE . . . . 1
ADHESIVE, GLASS . . . . . . . . . . . 1
10
11
13
L68784
L68510
L68315
L63700
L67865
Description
Qty.
Req.
CANOPY WELDMENT (CAB). . . . . 1
See note c
See note d
See note e
GRAB HANDLE (welded on) . . . . . 2
FRONT WINDOW GUARD. . . . . . . 1
a
552: S/N 1015 & Up
553: S/N 3368 & Up
b
552: Thru S/N 1014
553: Thru S/N 3367
c
552: S/N 1057 & Up
553: S/N 4519 & Up
d
552: S/N 1015 - 1056
553: S/N 3368 - 4518
e
552: Thru S/N 1014
553: Thru S/N 3367
908459/AP0603
552/553 Dynalift
Front and Rear Windows
(552: S/N 1015 and Up; 553: S/N 3368 and Up)
1
7
6
2
3
4
8
5
4
9
2
1
FRONT
2
13
1
6
12
1
8
7
8
2
2
10
11
908459/AP0603
14
PRINTED IN U.S.A.
552/553 Dynalift
(552: S/N 1015 and Up; 553: S/N 3368 and Up)
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
L68438
L520003
L68466
L68437
L67815
L67832
L67813
L50202
PRINTED IN U.S.A.
Description
Qty.
Req.
BOLT CAP . . . . . . . . . . . . . . . . . . 28
1/4-20 NYLON INSERT NUT . . . . 28
WINDOW PIVOT ROD . . . . . . . . . . 4
SHOULDER WASHER . . . . . . . . . 16
WINDOW HINGE WELDMENT . . . 4
RUBBER GROMMET. . . . . . . . . . 16
SCREW HEAD COVER . . . . . . . . 16
1/4-20X5/8” BUTTON HD BOLT . . 20
Ref.
No.
Part
No.
09
L67858
L99325
L68465
L99314
L67811
L67809
L67804
L67821
L99324
10
11
12
13
15
Description
Qty.
Req.
REAR GLASS (tilt-out window).
VINYL BULB SEAL (127”) . . . .
REAR GLASS (fixed window) . .
GASKET (132”) . . . . . . . . . . . .
WINDOW BRACKET . . . . . . . .
WINDOW SLIDE KNOB . . . . . .
WINDOW SLIDE BRACKET. . .
FRONT GLASS . . . . . . . . . . . .
VINYL BULB SEAL (118”) . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
4
4
4
1
1
908459/AP0603
552/553 Dynalift
(552: Thru S/N 1014; 553: Thru S/N 3367)
6
Window Hinge
3
8
7
5
Window Latch
4
1
2
9
10
FRONT
908459/AP0603
16
PRINTED IN U.S.A.
552/553 Dynalift
(552: Thru S/N 1014; 553: Thru S/N 3367)
Ref.
No.
01
02
03
04
05
Part
No.
L63740
L71393
L71392
L63946
L63132
L63727
PRINTED IN U.S.A.
Description
FRONT WINDOW GLASS . . .
PRIMER, GLASS ADHESIVE .
ADHESIVE, GLASS . . . . . . . .
HINGE SPACER . . . . . . . . . .
PLASTIC SPACER. . . . . . . . .
HINGE . . . . . . . . . . . . . . . . . .
.
.
.
.
.
.
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
.
06
07
08
09
10
L63563
L63560
L50629
L63738
L99315
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
2
4
2
17
Description
Qty.
Req.
RELEASE PIN . . . . . . . .
REAR LATCH . . . . . . . .
ROLL PIN 3/16X9/16 . . .
REAR WINDOW GLASS
GASKET (129”) . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
908459/AP0603
552/553 Dynalift
Windshield Wipers / Top and Front
2
1
3
8
4
7
5
6
14
9
13
12
11
10
NEW STYLE
WIPER MOTOR
SHOWN
15
16
17
20
18
22
19
21
908459/AP0603
18
PRINTED IN U.S.A.
552/553 Dynalift
Windshield Wipers / Top and Front
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
00ad
00e
00f
L68448
L68447
L68468
L63757
L63906
L68460
a
552: S/N 1015 & Up
553: S/N 3368 & Up
b
552: Thru S/N 1014
553: Thru S/N 3367
c
Use these parts to mount L61198 wiper motor
L63876
SMALL GROMMET . . . . . . . . .
L50214
1/4”-20X1” BOLT . . . . . . . . . . .
L50137
1/4” FLAT WASHER . . . . . . . . .
L50051
1/4”-20 FLANGE NUT . . . . . . .
L50155
5/8” FLAT WASHER . . . . . . . . .
Quantities shown are for both Top and Front Wipers
01
02
03
04g
05g
06
07
08a
09a
10a
11a
12a
13a
14
15
16
17
18
19
20
21
22
101279
L50145
L50061
NSS
NSS
L63546
L66843
L61198
L68459
L50896
L68439
L67832
L514001
L67813
L61199
L61200
L63932
L66850
L63931
L63335
L50655
L50896
L63699
L50051
L50202
L70649
L71394
PRINTED IN U.S.A.
NOZZLE, WASHER . . . . . . . . . . . . 2
3/8” FLAT WASHER . . . . . . . . . . . . 2
3/8”-16 FLANGE NUT . . . . . . . . . . 2
NUT (Included with item 7) . . . . . . . 1
WASHER (Included with item 7) . . . 1
RUBBER GROMMET. . . . . . . . . . . 2
WIPER MOTOR . . . . . . . . . . . . . . . 2
See note a (2 speed)
See note b and note c (Single speed)
WIPER COVER . . . . . . . . . . . . . . . 2
#10-24 NUT . . . . . . . . . . . . . . . . . . 2
NYLON SPACER . . . . . . . . . . . . . . 2
RUBBER GROMMET. . . . . . . . . . . 2
#10-24X1” RD HD SCREW . . . . . . 2
COVER, SCREW HEAD . . . . . . . . 2
WIPER ARM BLADE . . . . . . . . . . . 2
WIPER BLADE . . . . . . . . . . . . . . . 2
SWITCH, WASHER . . . . . . . . . . . . 1
SWITCH, WIPER . . . . . . . . . . . . . . 1
See note a (Two speed switch)
See note b (Single speed switch)
RELAY . . . . . . . . . . . . . . . . . . . . . . 1
#10-24X1/2” RD HD SCREW . . . . 1
#10-24 NUT . . . . . . . . . . . . . . . . . 1
BREAKER, CIRCUIT - 15AMP . . . . 1
1/4”-20 FLANGE NUT . . . . . . . . . . 4
1/4”-20 BUTTON HD BOLT . . . . . . 4
WASHER RESERVOIR W/PUMP. . 1
3/16” TEE, WASHER HOSE. . . . . . 1
19
Description
Qty.
Req.
-- ITEMS NOT SHOWN -HARNESS, WIPER . . . . . . . . . . . . 2
HARNESS, CAB OPT./WIPER. . . AR
HARNESS, WIPER/WASHER . . . AR
WIRE ASY, WASHER GRND . . . . . 1
WIRE ASY, WASHER MOTOR . . . . 1
RUBBER GROMMET. . . . . . . . . . . 2
d
Attaches to wiper motor.
e
Used instead of L68468 when unit is equipped
with heater only option. (Attaches to rocker
switches)
f
Used instead of L68447 when unit is equipped
with air conditioning option. (Attaches to rocker
switches)
g
Order P/N L99167 Wiper Hardware kit, which
includes the nut, washer and gasket.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
4
2
2
2
2
908459/AP0603
552/553 Dynalift
Side Door and Window
2
8
3
4
9
5
6
1
7
20
18
19
17
16
4
15
14
11
12
10
13
908459/AP0603
20
PRINTED IN U.S.A.
552/553 Dynalift
Side Door and Window
Ref.
No.
01
02
03
04
05
06
07
08
09a
09b
10
11
12
13
14
Part
No.
L63793
L99319
L63799
L63574
L520019
L50072
L63801
L67309
L99318
L67285
L63741
L99323
L71393
L71392
L99316
L67308
L63478
L99317
L61085
L63547
PRINTED IN U.S.A.
Description
Qty.
Req.
WELDMENT, UPPER DOOR . . . . . 1
VINYL DOOR SEAL (144”) . . . . . . 1
HANDLE, DOOR RELEASE . . . . . . 1
SPRING, DOOR RELEASE . . . . . . 1
1/2”-13 NUT . . . . . . . . . . . . . . . . . . 2
WELDMENT, DOOR REL LATCH. . 1
GLASS, UPPER DOOR . . . . . . . . . 1
GASKET, UPPER WINDOW (120”) 1
GLASS, LEFT SIDE . . . . . . . . . . . . 1
See note a (use with item 9a)
See note b (use with item 9b)
GASKET, LEFT WINDOW (89”) . . . 1
PRIMER, GLASS ADHESIVE . . . AR
ADHESIVE, GLASS . . . . . . . . . . AR
GASKET, LOWER WINDOW (76”) . 1
GLASS, LOWER DOOR. . . . . . . . . 1
WELDMENT, LOWER DOOR. . . . . 1
VINYL DOOR SEAL (69”) . . . . . . . 1
HANDLE, LOCKING. . . . . . . . . . . . 1
LATCH, DOOR / ROTARY . . . . . . . 1
Ref.
No.
Part
No.
15
16
17
18
L63548
L50152
L50202
L66907
L50212
L61086
L50211
19
20
Description
Qty.
Req.
STRIKER, DOOR. . . . . . . . . . . . .
1/2” LOCK WASHER . . . . . . . . . .
1/4”-20X5/8” BUTTON HD BOLT .
HANDLE, INSIDE DOOR . . . . . . .
#10-24X1/4” HEX HD SETSCRW
DOOR LOCK (UPPER DOOR). . .
1/4”-20X3/4” BOLT . . . . . . . . . . . .
.
.
.
.
.
.
.
1
1
4
1
1
1
4
-- ITEMS NOT SHOWN -L68441
21
DOOR ASSEMBLY (Complete). . . . 1
(includes all items shown except
items 8, 9, 15 & 16.)
a
552: S/N 1015 & Up
553: S/N 3368 & Up
b
552: Thru S/N 1014
553: Thru S/N 3367
908459/AP0603
552/553 Dynalift
Cab Mounts and Panels
22
1
2
21
3
4
5
6
20
19
8
8
6
18
7
8
17
9
15
10
16
11
12
7
13
14
6
908459/AP0603
22
PRINTED IN U.S.A.
552/553 Dynalift
Cab Mounts and Panels
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21g
Part
No.
L50294
L50151
L63269
L520019
L63870
L50230
L50141
L530004
L50567
L64124
L64197
L520007
L63458
L54002
L63519
L63559
L50051
L50202
L52025
L68347
L63884
L63265
L50143
L68449
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
1/2”-13X3-1/2” BOLT . . . . . . . . . . . 2
1/2” WASHER . . . . . . . . . . . . . . . . 2
MOUNT, VIBRATION ISOLATOR . . 2
FRONT COVER/FENDER . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 14
5/16” FLAT WASHER . . . . . . . . . . 10
5/16”-18 FASTENER NUT . . . . . . 10
5/8”X11X3-1/2” BOLT . . . . . . . . . . . 2
MOUNT, VIRATION ISOLATOR . . . 2
WASHER, ISOLATOR MOUNT . . . 2
5/8”-11 NYLON INSERT NUT . . . . . 2
COVER, BOTTOM OPER. . . . . . . . 1
SAFETY TREAD . . . . . . . . . . . . . . 1
(Cut into 6”x24” pieces)
FLOOR MAT (43”) . . . . . . . . . . . . . 1
WLDMNT, BRAKE ACCS COVR . . 1
1/4”-20 FLANGE NUT . . . . . . . . . . 2
1/4”-20X5/8” BUTTON HD BOLT . . 2
5/16”-18X3/4” BUTTON HD BOLT . 3
PANEL, JOYSTICK ACCESS . . . . . 1
See note a
See note b
See note c
5/16” LOCK WASHER . . . . . . . . . . 4
WELDMENT, REAR FENDER . . . . 1
Part
No.
22
23
Description
Qty.
Req.
L68784
L68510
L68315
CANOPY WELDMENT . . . . . . . . . . 1
See note d
See note e
See note f
00
00
L63813
L66842
-- ITEMS NOT SHOWN -HOLE PLUG 2-1/2” DIA. . . . . . . . AR
HOLE PLUG 2” DIA. . . . . . . . . . . AR
a
552: S/N 1015 & Up
553: S/N 3340 & Up
b
552: S/N 1006-1014
553: S/N 3012-3339
c
552: S/N 1001-1005
553: S/N 3001-3011
d
552: S/N 1057 & Up
553: S/N 4519 & Up
e
552: S/N 1015 - 1056
553: S/N 3368 - 4518
f
552: Thru S/N 1014
553: Thru S/N 3367
g
552: S/N 1015 & Up
553: S/N 3368 & Up
908459/AP0603
552/553 Dynalift
Steering Column and Shifter Group
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
1
2
3
14
5
4
5
6
7
13
8
12
9
T
11
L
P
10
908459/AP0603
24
11
R
STEER MOTOR
PORTS
PRINTED IN U.S.A.
552/553 Dynalift
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L40496
L41260
L41261
L50101
L68772
L500446
L500447
L67832
L500673
L50253
L64524
L444004
PRINTED IN U.S.A.
Description
Qty.
Req.
STEERING WHEEL (15”) . . . . . . . . 1
CAP, STEERING WHEEL. . . . . . . . 1
NUT, STEERING WHEEL. . . . . . . . 1
M5X.8X35mm HX SKTHD BOLT . . 2
SHIFTER, 3-SPD F-N-R. . . . . . . . . 1
HANDLE, TILT . . . . . . . . . . . . . . . . 1
KNOB, HANDLE . . . . . . . . . . . . . . 1
RUBBER GROMMET. . . . . . . . . . . 1
BOOT, DUST . . . . . . . . . . . . . . . . . 1
3/8”-16 BUTTON HD BOLT . . . . . . 4
CHECK VALVE . . . . . . . . . . . . . . . 1
ADAP, -8ORM -8JICM STR . . . . . . 3
Ref.
No.
Part
No.
Description
Qty.
Req.
12
13
14
L62842
L68713
L68773
ADAP, -4ORM -6JICM 90DEG . . . . 1
MOTOR, STEER, 17.9 DYN LS . . . 1
COLUMN, TILT . . . . . . . . . . . . . . . 1
00
L68774
-- ITEMS NOT SHOWN-WIRE HARNESS, FNR SHIFTER. . 1
NOTE: See hydraulic section for list of hoses
and locations.
25
908459/AP0603
552/553 Dynalift
(552: Thru S/N 1056; 553: Thru S/N 4518)
Hydraulic
Test Port
1
19
2
18
3
17
16
9
8
4
9
10
15
5
14
11
6
T
7
12
L
P
13
908459/AP0603
26
12
R
STEER MOTOR
PORTS
PRINTED IN U.S.A.
552/553 Dynalift
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
01
02
03
04
05
06
07
08
09a
10
11
12
13
14
15
Part
No.
L40496
L41260
L41261
L98786
L50202
L66059
L98787
L50101
L68280
L99425
L67832
L52026
L444004
L64524
L62842
L66753
L64523
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
STEERING WHEEL (15”) . . . . . . . . 1
CAP, STEERING WHEEL. . . . . . . . 1
NUT, STEERING WHEEL. . . . . . . . 1
SHIFT KNOB 1-2-3 SHIFTER. . . . . 1
1/4”-20X5/8” BOLT . . . . . . . . . . . . . 4
SHIFTER 1-2-3 . . . . . . . . . . . . . . . 1
(Includes items 4, 6 & 7)
SHIFT SWITCH . . . . . . . . . . . . . . . 2
M5X.8X35mm HX SKTHD BOLT . . 2
F-N-R SHIFTER . . . . . . . . . . . . . . . 1
BOOT . . . . . . . . . . . . . . . . . . . . . . 1
RUBBER GROMMET. . . . . . . . . . . 1
3/8”-16X1-1/4” BUTTN HD BOLT . . 4
ADAP, -8ORM -8JICM STR . . . . . . 3
CHECK VALVE . . . . . . . . . . . . . . . 1
MOTOR, STEER . . . . . . . . . . . . . . 1
See note b
See note c
16a
17
18
19
L66110
L63402
L62834
L62840
00
00a
L62933
L68281
a
Use P/N L99180 Replacement Kit:
552: Thru S/N 1014
553: Thru S/N 3345
b
552: S/N 1012 - 1014
553: S/N 3178 - 3367
c
552: Thru S/N 1011
553: Thru S/N 3177
Qty.
Req.
COLUMN, STEERING
HOSE, -4 X 48” . . . . .
TEST PORT. . . . . . . .
DUST CAP. . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
-- ITEMS NOT SHOWN-FEMALE COUPLER (Test Port) . . . 1
WIRE HARNESS, FNR SHIFTER. . 1
NOTE: See hydraulic section for list of hoses
and locations.
PRINTED IN U.S.A.
27
908459/AP0603
552/553 Dynalift
Seat Group
1
2
3
Located under the
seat on some models
5
6
7
4
5
8
7
6
STANDARD
SEAT
(SHOWN)
908459/AP0603
28
PRINTED IN U.S.A.
552/553 Dynalift
Seat Group
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
100135
L63811
L99454
L62459
L50208
L63810
L500948
L50061
L52026
L50056
PRINTED IN U.S.A.
Description
Qty.
Req.
SEAT, OPERATOR’S (Standard). .
SEAT, SUSPENSION (Optional) . .
ARM REST, SEAT (LH)(Std. Seat)
HOLDER, MANUAL. . . . . . . . . . .
1/4”-20X1/2” CUTTING SCREW. .
SEAT BELT ASSEMBLY . . . . . . . .
Used on standard seat
Used on suspension seat
3/8”-16 FLANGE NUT . . . . . . . . .
3/8”-16X1-1/4” BOLT . . . . . . . . . .
5/16”-18 FLANGE NUT . . . . . . . .
.
.
.
.
.
.
Ref.
No.
Part
No.
Description
Qty.
Req.
-- ITEMS NOT SHOWN --
1
1
1
1
2
1
.2
.2
.4
29
00a
00a
00a
00a
L52025
L520005
L50367
L50145
a
Used to mount suspension seat.
5/16”-18x3/4” BUTTN HD BOLT .
3/8”-16 LOCK NUT. . . . . . . . . . .
3/8”-16X1” BOLT . . . . . . . . . . . .
3/8” FLAT WASHER . . . . . . . . . .
.
.
.
.
.
.
.
.
4
4
4
8
908459/AP0603
552/553 Dynalift
Top Dash
35
34
DE-CLUTCH
OPTIONAL SWITCHES
1
33
36
ETHER
2
TURN
32
LIGHTS
3
31
HAZARD
30
4
5
FAN
38
28
WASHER
WIPER
37
9
8
6
29
7
13
27
12
26
11
10
16
14
15
25
17
21
19
20
19
18
14
22
908459/AP0603
23
30
24
2
PRINTED IN U.S.A.
552/553 Dynalift
Top Dash
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
Part
No.
L63674
L50141
L52025
L66011
L50417
L68638
L63688
L63640
L66437
L63610
072340
L520017
L50546
L50056
L62484
L50230
L650012
L50835
L41848
L63699
089069
089070
L43965
L43964
L63941
L63936
L63942
L63935
L67674
L50896
L50655
L277568
L63932
L66850
L63931
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
30
PLATE, LEVEL INDICATOR . . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . . 6
5/16”-18X3/4” BUTTN HD BOLT. . . 2
INDICATOR, FRAME LEVEL . . . . . 1
#8X1” RND HD MACH SCREW . . 2
STEER SELECT SWITCH . . . . . . . 1
PANEL, RECESSED GUAGE. . . . . 1
GUAGE, FUEL. . . . . . . . . . . . . . . . 1
GUAGE, WATER TEMP.. . . . . . . . . 1
GUAGE, LIGHT CLUSTER. . . . . . . 1
GUAGE, HOUR METER . . . . . . . . 1
#6-32 NYLON INSERT NUT. . . . . . 2
#6-32X3/4” RD MACH SCREW . . . 2
5/16”-18 FLANGE NUT . . . . . . . . . 3
BRACKET, SWITCH MOUNT . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . . 1
SWITCH, BRAKE LIGHT . . . . . . . . 1
5/16-18X2” BOLT . . . . . . . . . . . . . . 2
SWITCH, PUSH BUTTON . . . . . . . 2
BREAKER, CIRCUIT 15 AMP. . . . . 1
SWITCH, IGNITION . . . . . . . . . . . . 1
KEY ONLY . . . . . . . . . . . . . . . . . . 1
SPACER, PARK BRAKE LEVER . . 1
SPACER, PARK BRAKE LEVER . . 1
SWITCH PANEL (3 HOLES). . . . . . 1
SWITCH PANEL (NO HOLES)
SWITCH PANEL (6 HOLES)
SWITCH PANEL (9 HOLES)
SWITCH PANEL (A/C - 7 HOLES.)
#10-24 NUT . . . . . . . . . . . . . . . . . . 4
#10-24X1/2” RD MACH. SCREW . . 4
LEVER, PARK BRAKE . . . . . . . . . . 1
SWITCH, WASHER SYSTEM . . . . 1
SWITCH, WIPER . . . . . . . . . . . . . 1
See note a (2-Speed) . . . . . . . . . . . 1
See note b (Single Speed) . . . . . . . 1
31
32
33
34
35
36
37
38
L66849
L63931
L63934
L63937
L68054
NA
L63938
L63933
L63689
L50202
Qty.
Req.
SWITCH, HEATER FAN . . . . .
See note a (2 Speed)
See note b (Single Speed)
SWITCH, HAZARD LIGHTS . .
SWITCH, LIGHTS . . . . . . . . .
SWITCH, ETHER . . . . . . . . .
OTHER OPTION . . . . . . . . . .
SWITCH, CLUTCH CUT OUT
SWITCH, TURN LIGHTS . . . .
GUAGE, COVER PANEL . . . .
1/4”-20X5/8” BUTT. HD BOLT.
....1
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
1
4
L67681
-- ITEMS NOT SHOWN-(SWITCHES)
SWITCH, AIR COND.. . . . . . . . . . . 1
L63837
L63835
L63887
(LOAD CHARTS)
553 LOAD CHARTS PACKAGE . . . 1
552 LOAD CHARTS PACKAGE . . . 1
1/4”-20 U-BOLT . . . . . . . . . . . . . . . 1
L63633
L42342
L50607
L47275
31
Description
(PARKING BRAKE)
PARK BRAKE CABLE . .
3/8”X1-1/4” CLEVIS PIN.
1/8”X1” COTTER PIN. . .
CLAMP, BRAKE CABLE.
a
552: S/N 1015 & up
553: S/N 3368 & up
b
552: Thru S/N 1014
553: Thru S/N 3367
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
908459/AP0603
552/553 Dynalift
Under Dash
16
15
17
3
1
14
4
2
5
6
7
8
13
11
10
7
9
10
12
11
FRONT
908459/AP0603
32
PRINTED IN U.S.A.
552/553 Dynalift
Under Dash
Ref.
No.
Part
No.
01a
L650004
L68447
L650012
L66437
072340
L41848
L62132
L63699
L63872
02
03
04
05
06
07
08
09
10
11
12
L63894
L62949
L650004
L650005
L66736
L63335
13
L63335
14b
14c
15
16
17
Description
Qty.
Req.
BLOCK, TERMINAL 3 BANK . . . . . 1
HARNESS, CAB OPTION . . . . . . . 1
BRAKE LIGHT SWITCH. . . . . . . . . 1
GUAGE, WATER TEMP . . . . . . . . . 1
GUAGE, HOURMETER . . . . . . . . . 1
SWITCH, PUSH BUTTON . . . . . . . 2
BUZZER, 12 VDC . . . . . . . . . . . . . 1
BREAKER, CIRCUIT 15 AMP . . . AR
HARNESS, LIGHT PKG . . . . . . . . . 1
(Used with Deluxe Light Pkg)
FLASHER . . . . . . . . . . . . . . . . . . . 1
RELAY, DPDT 12VDC . . . . . . . . AR
BLOCK, TERMINAL 3 BANK . . . . AR
JUMPER . . . . . . . . . . . . . . . . . . AR
CLINCH JUMPER . . . . . . . . . . . AR
RELAY . . . . . . . . . . . . . . . . . . . . . . 1
(Used with windshield wipers)
RELAY . . . . . . . . . . . . . . . . . . . . . . 1
(Used for electrical system)
SWITCH, IGNITION . . . . . . . . . . . . 1
KEY ONLY . . . . . . . . . . . . . . . . . . 1
START SWITCH WITH KEY. . . . . . 1
KEY ONLY . . . . . . . . . . . . . . . . . . 1
GUAGE, LIGHT CLUSTER. . . . . . . 1
GUAGE, FUEL. . . . . . . . . . . . . . . . 1
SWITCH, STEER SELECT. . . . . . . 1
089069
089070
L40417
L41852
L63610
L63640
L68638
Ref.
No.
Part
No.
00
00
00
00
00
00
00
00
00
00
00
L63142
L63606
L63611
L63751
L63752
L63753
L64090
L64097
L64970
L66053
L66162
WIRE ASY . . . . . . . . . . . . . . . . . . . 1
WIRE ASY, 16GA.X18” RED . . . . . 1
WIRE ASY . . . . . . . . . . . . . . . . . . . 2
WIRE ASY, RELAY TO BUZZER . . 1
WIRE ASY, 16GA.X8” BLACK . . . . 1
WIRE ASY, RELAY TO BLOCK . . . 2
WIRE ASY, 14GAX6” BLACK . . . . . 5
WIRE ASY, 8” .25 SLIDE #10 EYE . 2
WIRE ASY, 16GAX6” . . . . . . . . . . . 1
00
00
00
L63647
L63335
L68056
(SWITCHES)
TIME DELAY SW. 2-PIN. . . . . . . . . 1
TIME DELAY SWI. 5-PIN . . . . . . . . 1
PREHEAT SW. (Perkins Eng.) . . . . 1
a
Terminal block and wire harness used for units
equipped with heater only option. Units equipped
with Air Conditioning uses L68468 harness and
no terminal block.
b
552: S/N 1015 & Up
553: S/N 3248 & Up
c
552: Thru S/N 1014
553: Thru S/N 3247
d
552: S/N 1057 & Up
553: S/N 4519 & Up
e
552: Thru S/N 1056
553: Thru S/N 4518
-- ITEMS NOT SHOWN --
00
L68777
L63550
(WIRE ASSEMBLIES)
MAIN FRAME WIRE HARNESS. . . 1
See note d
See note e
PRINTED IN U.S.A.
33
Description
Qty.
Req.
908459/AP0603
552/553 Dynalift
Accelerator and Brake Pedals
FRONT
OPTIONAL
CLUTCH CUT-OUT
40
39
38
37
1
35
36
3
2
35
34
5
TO FRONT
AXLE
4
33
9
10
11
7
6
8
32 31
24
25
26
23
27
22
28
30
13
12
22
18 19 20
29
18
21
20
14
19
15
16
908459/AP0603
TO REAR
AXLE
17
34
PRINTED IN U.S.A.
552/553 Dynalift
Accelerator and Brake Pedals
Ref.
No.
Part
No.
01
02
03
04a
L63230
L50235
L50056
L63172
05
06
07
L66156
L50151
L48179
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
P470079
L64890
L67330
L50628
L63564
L520004
L50835
L51591
L63651
L63651
L50607
L580005
L50072
L63373
L44859
L10465
L510041
L50150
L520005
L50145
L50261
L63382
L63382
100012
L446044
L62741
L63363
PRINTED IN U.S.A.
Description
Qty.
Req.
PAD, BRAKE PEDAL . . . . . . . . . . . 1
5/16”-18X1-1/4” BOLT . . . . . . . . . . 2
5/16”-18 FLANGE NUT . . . . . . . . . 2
BRAKE LEVER ASSEMBLY . . . . . . 1
(Includes item 7)
BRAKE LINKAGE, WELDMENT. . . 1
1/2” FLAT WASHER . . . . . . . . . . . . 1
BRONZE BUSHING . . . . . . . . . . . . 2
(Included with item 4)
SPACER . . . . . . . . . . . . . . . . . . . . 1
SWITCH, BRAKE LIGHT . . . . . . . . 1
PIN, BRAKE LEVER PIVOT . . . . . . 1
ROLL PIN, .19X1 . . . . . . . . . . . . . . 1
SWITCH, DIFF. PRESSURE . . . . . 1
5/16”-18 NYLON INSERT NUT. . . . 2
5/16”-18X2” BOLT . . . . . . . . . . . . . 2
HOSE, -4 A4/DM4 17” . . . . . . . . . . 1
HOSE, -4 AT/DM4 17” . . . . . . . . . . 1
1/8”X1” COTTER PIN. . . . . . . . . . . 2
YOKE, CLEVIS 1/2”-13 . . . . . . . . . 2
1/2”-13 NUT . . . . . . . . . . . . . . . . . . 2
ROD, BRAKE VALVE . . . . . . . . . . . 1
PIN, CLEVIS 1/2”X27/64” . . . . . . . . 2
ZERK, GREASE 1/4”-28. . . . . . . . . 1
7/16”-20X1” BOLT . . . . . . . . . . . . . 2
7/16” LOCK WASHER . . . . . . . . . . 2
3/8” FLAT WASHER . . . . . . . . . . . . 6
3/8”-16X1-1/2” BOLT . . . . . . . . . . . 6
HOSE, -4 A4/DS6 88”. . . . . . . . . . . 1
HOSE, -4 A4/DS6 88”. . . . . . . . . . . 1
ADAP, -4JICFS -4JICM 90DEG . . . 1
ADAP, -4 SWIVEL TEE . . . . . . . . . 2
ADAP, HYDROMAX -4JICM STR . . 2
VALVE, BRAKE MASTER CYL. . . . 2
(Refer to hydraulics for breakdown)
Ref.
No.
Part
No.
35
36
37
L63629
L62926
L68641
L52024
L50051
L99196
L446044
L51622
L63286
38
39
40
Qty.
Req.
BRACKET, THROTTLE RETRN . . . 2
SPRING, CABLE TENSION . . . . . . 1
PEDAL, ACCELERATOR . . . . . . . . 1
1/4”-20X1” BUTTN HD BOLT. . . . . 3
1/4”-20 FLANGE NUT . . . . . . . . . . 3
BOOT . . . . . . . . . . . . . . . . . . . . . . 1
ADAP, -4 SWIVEL TEE . . . . . . . . . 1
ADAP, 1/4”NPTF -4JICFS. . . . . . . . 1
SWITCH, CLUTCH CUT-OUT . . . . 1
00
-- ITEMS NOT SHOWN-(Throttle)
L63420
THROTTLE CABLE . . . . . . . . . .
L64664
COUPLER (John Deere) . . . . . .
L64663
THROTTLE ROD (John Deere) .
L580009
BALL JOINT (to inj. pump). . . . .
L50050
HEX NUT #10-32 . . . . . . . . . . .
(Brake)
L561004
RETURN SPRING (Brake lever).
(attaches to item 4)
(Clutch Cut-Out)
L66135
HARNESS, CLUTCH CUT-OUT .
a
L98709
00
00
35
Description
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
..1
..1
BRAKE LEVER KIT . . . . . . . . . . . . 1
(Includes items 4, 7, 8, 10, 11 & 23)
908459/AP0603
552/553 Dynalift
Heater
(No Air Conditioning)
1
2
FRONT
3
5
4
7
6
8
Heater shut-off valve
DEFROSTER FAN
(OPTIONAL)
12
13
14
ENGINE
(Left Side)
10
11
9
5
16 15
REAR OF
MACHINE
5
17
908459/AP0603
36
PRINTED IN U.S.A.
552/553 Dynalift
Heater
(No Air Conditioning)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11c
12
13
14
15
16
17
Part
No.
L63545
L99320
L66849
L63930
L50056
L75956
L52025
L63536
L66997
L500448
L68592
L69718
L68591
L66986
L50208
L66993
L50896
L50655
101158
L42448
L67832
PRINTED IN U.S.A.
Description
Qty.
Req.
GRILL, DEFROSTER . . . . . . . . . . .
TUBING, DUCT (12”) . . . . . . . . . . .
SWITCH, HEATER. . . . . . . . . . . . .
See note a (2 Speed)
See note b (Single Speed)
5/16”-18 FLANGE NUT . . . . . . . . .
#10 HOSE CLAMP. . . . . . . . . . . . .
5/16”-18X3/4” BUTTN HD BOLT. . .
BRACKET, CAB HEATER . . . . . . .
HEATER, CAB . . . . . . . . . . . . . . . .
BLOWER MOTOR (no fan blade) .
SHUTOFF, MANUAL . . . . . . . . . . .
ADAP, 3/8”NPTF 18MX1.5 ORING .
STEM, HOSE. . . . . . . . . . . . . . . . .
DEFROSTER FAN (Optional) . . . . .
1/4”-20X1/2” SELF TAP SCREW . .
BRACKET, DEFROSTER FAN . . . .
#10-24 NUT . . . . . . . . . . . . . . . . . .
#10-24 BOLT . . . . . . . . . . . . . . . . .
HARNESS, DEFROSTER FAN. . . .
CONNECTOR, 14-16 GA. BUTT . .
RUBBER GROMMET . . . . . . . . . .
1
1
1
5
4
2
1
1
1
1
2
1
1
2
1
3
3
1
4
2
37
Ref.
No.
Part
No.
Description
Qty.
Req.
00
00
L66842
L63813
00
00
L68447
L99449
00
00d
00d
00d
(HEATER HOSE & ADAPTERS)
L99321
HOSE, HEATER 5/8”x216” . . . . . . .
L51060
ADAP, 1/2”x3/8” 45 DEGREE . . . . .
L51243
ADAP, -8ORM -6UFS UNION STR
L51052
ADAP, 3/8 . . . . . . . . . . . . . . . . . . .
-- ITEMS NOT SHOWN-HOLE PLUG, 2” DIA. . . . . . . . . . . AR
HOLE PLUG, 2-1/2” DIA . . . . . . . AR
(ELECTRICAL)
HARNESS, CAB OPTION . . . . . . . 1
RESISTOR, 12W/3 OHM . . . . . . . . 1
(used with 2 speed heater switch)
a
552: S/N 1015 & up
553: S/N 3368 & up
b
552: Thru S/N 1014
553: Thru S/N 3367
c
L447005 adapter replaces L68591 hose stem
and one L69718 adapter (item 10)
d
552: Thru S/N 1020
553 w/ JD Natural Thru S/N 3916
553 w/ JD Turbo Thru S/N 3629
2
1
1
1
908459/AP0603
552/553 Dynalift
Air Conditioning Group
1
FRONT
2
23
3
Boom
4
Condenser
23
5
9
10
8
7
11
12
6
17
12
13
14
16, 25
22
18,23,25
15
19 23
23
20, 24, 26
Back of Cab
21, 24, 26
13
Under Seat
15
15
FRONT
908459/AP0603
38
PRINTED IN U.S.A.
552/553 Dynalift
Air Conditioning Group
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L68288
L50208
L68151
L52026
L68148
L50823
L50143
L68149
L66679
L50367
L66675
L66588
L50836
08
09
10
11
12
13
14
15
16
17
18
19
L68463
L68463
L67638
L67681
L67674
L99010
L63545
NSS
L67732
NSS
L67655
L50277
L66547
L68461
L67628
L50403
L50251
L67226
L50403
Description
Qty.
Req.
COVER WELDMENT . . . . . . . . . . . 1
SELF TAP SCREW 1/4-20X1/2 . . . 4
CONDENSOR MT. WELD. . . . . . . . 1
3/8”-16X1-1/4” BUTT. HD. BOLT . . 4
MOUNT ANGLE . . . . . . . . . . . . . . . 2
5/16”-18X1” BOLT . . . . . . . . . . . . . 4
5/16”-18 LOCKWASHER . . . . . . . 4
SPACER . . . . . . . . . . . . . . . . . . . . 2
ELECTRIC CONDENSOR . . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . 4
V-BELT . . . . . . . . . . . . . . . . . . . . . 1
ADD-ON PULLEY (J.Deere Eng.) . . 4
3/8”-16X1-3/4” BOLT . . . . . . . . . . . 4
RECEIVER/DRYER . . . . . . . . . . . . 1
See note a (Dryer w/Switch)
DRYER BINARY SWITCH. . . . . . . 1
See note b
ROCKER SWITCH (A-C & HEAT) . 1
A/C SWITCH PANEL . . . . . . . . . . . 1
FAN SPEED SWITCH . . . . . . . . . . 1
GRILLE . . . . . . . . . . . . . . . . . . . . . 2
FLEX. DUCT, 2” DIA . . . . . . . . . . AR
ADAPTER 2-1/2 TO 2” . . . . . . . . . . 2
FLEX. DUCT, 2-1/2” DIA . . . . . . . AR
ADJUST. BRACKET. . . . . . . . . . . . 1
3/8”-16X3-1/2” BOLT . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . 1
COMPRESSOR . . . . . . . . . . . . . . . 1
See note a (R12)
See note b (R134a)
3/8”-16X1-1/4” BOLT . . . . . . . . . . 2
3/8”-16X3/4” BOLT . . . . . . . . . . . . 1
COMPRESSOR MOUNT . . . . . . . . 1
3/8”-16X1-1/4” BOLT . . . . . . . . . . 4
Ref.
No.
Part
No.
20
23
24
25
26
L67630
L500768
L50230
L68451
L50823
L67629
L99124
L50486
L520005
L50056
L50147
L50141
27
28
29
30
31
32
(AIR COND. HOSES)
NOTE: Hoses Are Cut Length, Not Overall
L68276
A/C HOSE ASY 5/16X61 . . . .
L68277
A/C HOSE ASY 5/16X100 . . .
L68156
A/C HOSE ASY 5/16X58 . . . .
L66976
A/C HOSE ASY 1/2X61 . . . . .
L68274
A/C HOSE ASY 13/32X71 . . .
L66977
A/C HOSE ASY 13/32X81 . . .
21
22
L68467
L99448
L99141
L99847
L99654
L75956
a
b
31
552:
553:
552:
553:
Description
Qty.
Req.
EVAPORATOR/BLOWER . . . . . . . . 1
FAN MOTOR W/BLAD . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 2
AIR CHANNEL WELDMENT. . . . . . 1
5/16”-18X1” BOLT . . . . . . . . . . . . 4
OUTSIDE AIR KIT . . . . . . . . . . . . . 1
A/C FILTER. . . . . . . . . . . . . . . . . . 1
1/4”-20X5/8” BOLT . . . . . . . . . . . . 6
3/8”-16 NYLON INSERT NUT . . . 14
5/16”-18 FLANGE NUT . . . . . . . . 10
3/8” LOCKWASHER . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . 6
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
-- ITEMS NOT SHOWN -A-C HARNESS . . . . . . . . . . . . . . . 1
IN-LINE FUSE, 20 AMP . . . . . . . . . 1
HOSE, HEATER 5/8”x120” . . . . . AR
HOSE, HEATER 5/8”X192” . . . . . AR
HOSE, HEATER 5/8”X216” . . . . . AR
#10 HOSE CLAMP. . . . . . . . . . . . . 4
S/N 1015 & Up
S/N 3368 & Up
Thru S/N 1014
Thru S/N 3367
32
COMPRESSOR
CONDENSOR
AIR COND. HOSES
RECV./DRYER
29
30
28
27
EVAPORATOR/
BLOWER
PRINTED IN U.S.A.
39
908459/AP0603
Chassis
552/553 Dynalift
Frame Hoods and Covers
(552: S/N 1015 & Up; 553: S/N 3340 & Up )
1
27
2
5
6
3
9
7
9
8
2
10
4
26
25
11
12
13
9
5
3
4
23
14
24
22
21
20
15
16
9
2
11
11
19
18
908459/AP0603
17
16
40
PRINTED IN U.S.A.
552/553 Dynalift
Chassis
(552: S/N 1015 & Up; 553 S/N; 3340 & Up )
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
Part
No.
L50823
L50141
L50056
L62722
L62720
L68192
L68133
L68134
L68135
L68171
L50230
L68310
L530004
L68182
L68185
NSS
L68205
L67756
L50145
L50442
L41847
L52025
L68866
L68210
L68200
L63913
L50755
L63756
PRINTED IN U.S.A.
Description
Qty.
Req.
5/16”-18x1” BOLT. . . . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . 30
5/16” FLANGE NUT . . . . . . . . . . . . 5
FASTNER RECEPTACLE. . . . . . . . 4
FASTNER STUD . . . . . . . . . . . . . . 4
TOP ACCESS PANEL . . . . . . . . . . 1
FASTNER, WING STYLE . . . . . . . . 4
STAR LOCK WASHER . . . . . . . . . 4
QUICK NUT . . . . . . . . . . . . . . . . . 4
RADIATOR GRILLE . . . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 26
REAR HOOD WELDMENT . . . . . . 1
5/16” NUT/CLIP RETAINING . . . . 24
REAR HOOD EXT WLDMNT . . . . . 1
RADIATOR PANEL WLDMNT (LH) . 1
MAIN FRAME WELDMENT . . . . . . 1
FRONT HOOD WELDMENT . . . . . 1
MUFFLER GUARD WLDMNT . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . . 4
3/8”-16X1-1/4” SELF TAP BOLT . . . 4
HORN, 12V ELEC B21. . . . . . . . . . 1
5/16”-18X3/4” BUTTN HD BOLT. . . 4
FRAME FRONT PANEL . . . . . . . . . 1
See note a
See note b
ACCESS COVER (Battery) . . . . . . 1
MIRROR BRACKET WLDMENT. . . 1
5/16”-18 ACORN NUT . . . . . . . . . . 5
MIRROR, CONVEX 6-1/2”X10” . . . 1
Ref.
No.
Part
No.
26
27
L68193
L68186
L68777
L63550
L68268
L550003
L63870
L68449
L63864
41
Description
Qty.
Req.
MID HOOD SECT. WLDMNT . . . . . 1
RADIATOR PANEL WLDMNT (RH) 1
-- ITEMS NOT SHOWN -HARNESS, MAIN FRAME . . . . . . . 1
See note c
See note d
RUBBER MOLDING . . . . . . . . . . AR
(used around various panels)
5/16”-18X3/4” WELD STUDS . . . . . 4
(used to fasten mirror brkt to tank)
(FENDERS)
FENDER, LEFT FRONT. . . . . . . . . 1
FENDER, LEFT, REAR . . . . . . . . . 1
FENDER, RIGHT SIDE . . . . . . . . . 2
(used on both front and back)
a
552: S/N 1075 & Up
553: S/N 4832 & Up
b
552: Thru S/N 1074
553: Thru S/N 4831
c
552: S/N 1057 & Up
553: S/N 4519 & Up
d
552: Thru S/N 1056
553: Thru S/N 4518
908459/AP0603
Chassis
552/553 Dynalift
(552: Thru S/N 1014; 553: Thru S/N 3339 )
6
5
4
3
7
2
1
8
15
9
11
10
14
12
908459/AP0603
13
42
PRINTED IN U.S.A.
552/553 Dynalift
Chassis
(552: Thru S/N 1014; 553: Thru S/N 3339)
Ref.
No.
01
02
03
04
05
Part
No.
L63509
L50230
L50141
L530004
L63506
L50230
L50141
L530004
L63513
L62720
L62721
L62722
L63516
L50230
L50141
L530004
L63503
L63361
L50230
L530004
PRINTED IN U.S.A.
Description
Qty.
Req.
FRONT COVER . . . . . . . . . . . . . . . 1
5/16”-18X3/4 BOLT . . . . . . . . . . . . 4
5/16” FLAT WASHER . . . . . . . . . . 4
5/16”-18 RET. NUT FASTNR . . . . . 4
TRANSMISSION COVER. . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . 10
5/16” FLAT WASHER . . . . . . . . . 10
5/16”-18 RET. NUT FASTNR. . . . 10
ACCESS COVER. . . . . . . . . . . . . . 2
STUD FASTENER . . . . . . . . . . . . 8
RETAINER . . . . . . . . . . . . . . . . . . 8
RECEPTACLE . . . . . . . . . . . . . . . 8
FRONT ENGINE COVER. . . . . . . . 1
5/16” -18X3/4” BOLT . . . . . . . . . . 3
5/16” FLAT WASHER . . . . . . . . . . 3
5/16”-18RET. NUT FASTNR. . . . . 3
ENG. TOP COVER (Older Style) . . 1
ENG. TOP COVER. . . . . . . . . . . . . 1
(Newer Style, Longer Sides)
5/16”-18X3/4” BOLT . . . . . . . . . . 10
5/16”-18 RET. NUT FASTNR. . . . 10
Ref.
No.
Part
No.
06
L63496
L50230
L50143
L63524
L50230
L50141
L530004
L63756
L63913
L50755
L41847
L50442
L50145
L67756
NSS
07
08
09
10
11
12
13
14
15
Description
Qty.
Req.
RADIATOR COVER . . . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 8
5/16” LOCKWASHER . . . . . . . . . . 8
REAR VALVE COVER . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 8
5/16” FLAT WASHER . . . . . . . . . . 8
5/16”-18 RET. NUT FASTNR. . . . . 8
MIRROR, CONVEX 6-1/2”X10” . . . 1
MIRROR BRACKET WLDMENT. . . 1
5/16”-18 ACORN NUT . . . . . . . . . . 5
HORN, 12V ELEC B21. . . . . . . . . . 1
3/8”-16X1-1/4” SELF TAP BOLT . . . 4
3/8” FLAT WASHER . . . . . . . . . . . . 4
MUFFLER GUARD WLDMNT . . . . 1
FRAME . . . . . . . . . . . . . . . . . . . . . 1
-- ITEMS NOT SHOWN -HARNESS, MAIN FRAME . . . . . . . 1
RUBBER MOLDING . . . . . . . . . . AR
(used around various panels)
L550003
5/16”-18X3/4” WELD STUDS . . . . . 4
(used to fasten mirror brkt to tank)
L63550
L68268
43
908459/AP0603
Chassis
552/553 Dynalift
Hydraulic and Fuel Tanks
3
7
4
6
1
2
2
8
5
9
23
24
22
10
11
12
14
15
21
13
16
17
20
19
18
FRONT
INSIDE TANK
908459/AP0603
44
PRINTED IN U.S.A.
552/553 Dynalift
Chassis
Hydraulic and Fuel Tanks
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
Part
No.
L63215
L99163
L62831
L98568
L97489
L97489
L63505
L63798
L61867
L50418
L41854
L63217
L50286
L520019
L442022
L67616
L72175
L81690
L68619
L444002
L446048
L441010
L61620
L49327
L43221
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
21
CAP, HYDRAULIC ASSEMBLY . . . 1
GASKET, FILLER NECK . . . . . . . . 4
ASSEMBLY, IN-TANK FILTER . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . 1
ELEMENT (item #4) . . . . . . . . . . . 1
ELEMENT . . . . . . . . . . . . . . . . . . . 1
ADAP -12JICM -24NPTM STR . . . . 1
CAP, FUEL ASSEMBLY . . . . . . . . . 1
SENDER, FUEL LEVEL . . . . . . . . . 1
#10-32X1/2” RD MACH SCREW . . 5
GASKET, FUEL SENDER . . . . . . . 1
FUEL TANK WELDMENT. . . . . . . . 1
(Includes item 13)
1/2”-13X1-3/4” BOLT . . . . . . . . . . . 8
ADAP -4JICM -4NPTM. . . . . . . . . . 1
HOSE -4 73”(Fuel Return). . . . . . . 1
PLUG, 1/2” NPT . . . . . . . . . . . . . . . 1
ADAP -6JICM -4NPTM. . . . . . . . . . 1
HOSE -6 73” (Fuel Supply) . . . . . . 1
ADAP -6ORM -6JICM STR. . . . . . . 3
PLUG, -6ORM . . . . . . . . . . . . . . . . 1
ADAP -24NPTM -24JICM STR . . . . 1
1-1/2” THREADED PIPE . . . . . . . . 1
STRAINER, HYD. OIL . . . . . . . . . . 1
PLUG, 1/2”-14 MAGNETIC . . . . . . 1
22
23
24
Qty.
Req.
L68763
L63216
L65144
L50230
L65142
HYDRAULIC TANK . . . . . . . . . . . . 1
(Includes items 18-20)
See note a
See note b
GASKET, RUBBER . . . . . . . . . . . . 1
5/16”-18X1-1/4” BOLT . . . . . . . . . 10
PLATE, HYDRAULIC TANK COVR. 1
L75906
-- ITEMS NOT SHOWN -CLAMP, HOSE #6 . . . . . . . . . . . . . 1
L63864
L63756
L63913
L50755
L550003
45
Description
(Fenders)
FENDER, RIGHT SIDE . . . . . . . . . 2
(fits both front and rear)
(Mirror)
MIRROR, CONVEX 6-1/2”X10”
BRACKET, MIRROR . . . . . . . .
5/16”-18 ACORN NUT. . . . . . .
WELD ON STUDS . . . . . . . . .
a
552: S/N 1057 & Up
553: S/N 4519 & Up
b
552: Thru S/N 1056
553: Thru S/N 4518
.
.
.
.
.
.
.
.
.
.
.
.
1
1
5
4
908459/AP0603
Chassis
552/553 Dynalift
Battery Group
1
2
10
4
3
9
5
8
6
7
FRONT
908459/AP0603
46
PRINTED IN U.S.A.
552/553 Dynalift
Chassis
Battery Group
Ref.
No.
01
02
03
04
05
Part
No.
L63334
L630004
L630001
L630003
L63248
PRINTED IN U.S.A.
Description
BAR, BATTERY HOLD DOWN .
GROUND STRAP, 14GA.X14” .
CABLE, NEG. BATTERY . . . . .
BOOT, RUBBER . . . . . . . . . . .
CABLE, POS. BATTERY . . . . .
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
06
07
08
09
10
L41847
NSS
L50061
L70146
L530003
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
47
Description
Qty.
Req.
HORN, 12V ELEC B2I . . . . . . .
BATTERY, 4DLT TYPE . . . . . . .
3/8”-16 FLANGE NUT . . . . . . .
ROD, BATTERY HOLD DOWN
3/8”-16 WING NUT. . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
4
2
2
908459/AP0603
Chassis
552/553 Dynalift
Lights
STANDARD
TAIL LIGHTS
6
1
1
2
5
3
4
1
3
7
10
13
9
8
8
11
9
10
12
11
DELUXE
TAIL LIGHTS
FRONT
908459/AP0603
48
PRINTED IN U.S.A.
552/553 Dynalift
Chassis
Lights
Ref.
No.
01
02
03
04
05
06
07
08a
09a
10a
11
12b
13b
Part
No.
L4445
L50367
L63853
L520005
L4446
L62814
L50230
L50056
L70200
L50230
L50056
L63816
L63814
L63815
L68304
L50209
L50136
L99204
L99205
PRINTED IN U.S.A.
Description
LIGHT, HEAD. . . . . . . . . . . . .
3/8”-16X1” BOLT . . . . . . . . . .
MOUNT, WORK LIGHT . . . . .
3/8”-16 NYLON INSERT NUT.
LIGHT, TAIL . . . . . . . . . . . . . .
BRACKET, LIGHT . . . . . . . . .
5/16”-18X3/4” BOLT . . . . . . .
5/16”-18 FLANGE NUT . . . . .
BACKUP ALARM . . . . . . . . . .
5/16”-18X3/4” BOLT . . . . . . .
5/16”-18 FLANGE NUT . . . . .
LIGHT, BACKUP . . . . . . . . . .
LIGHT, STOP-TAIL . . . . . . . . .
LIGHT, TURN. . . . . . . . . . . . .
BRACKET, TAIL LIGHTS . . . .
1/4”-20X1/2” BOLT . . . . . . . .
1/4” LOCK WASHER. . . . . . .
HEAD LIGHT, RIGHT SIDE . .
HEAD LIGHT, LEFT SIDE . . .
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Ref.
No.
3
2
2
2
2
1
2
2
1
2
2
2
2
2
2
4
4
1
1
a
a
49
Part
No.
L64987
L63873
L63874
L63872
L63546
L67832
L63595
L63284
Description
Qty.
Req.
-- ITEMS NOT SHOWN -HARNESS, BRAKE LIGHTS . . . .
HARNESS, LIGHT ASSY (Front). .
HARNESS, TAIL LIGHT . . . . . . . .
HARNESS, UNDER DASH. . . . . .
GROMMET, RUBBER . . . . . . . . .
GROMMET, RUBBER . . . . . . . . .
REAR LIGHTS HARNESS . . . . . .
WORK LIGHTS HARNESS . . . . .
a
Used with deluxe light package
b
L63854
b
b
L99423
NSS
.
.
.
.
.
.
.
.
1
1
1
1
1
2
1
1
HEADLIGHT KIT . . . . . . . . . . . . . . 1
(includes items 12 & 13)
SEALED BEAM ONLY . . . . . . . . . . 1
TURN SIGNAL BULB (GE 1157)
908459/AP0603
Engine
552/553 Dynalift
External Engine Components Group
1
23
4
2
3
5
22
6
21
20
19
18
17
JOHN DEERE
4045TF (SHOWN)
16
8
9
7
15
14
10
11
12
13
908459/AP0603
REAR
50
PRINTED IN U.S.A.
552/553 Dynalift
Engine
External Engine Components Group
Ref.
No.
Part
No.
01
02a
NSS
L41179
L63609
L68571
L64437
L69166
L68619
L67616
L75906
L66606
L64664
L64663
L580009
L50319
L64124
L64197
L520007
L64646
03a
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22b
23a
L68596
L63453
L67685
L63262
L63443
L68595
L68595
L67217
L67578
L63261
L63442
L50667
L69718
L68592
L68591
L68614
L99161
NSS
L447005
L68604
PRINTED IN U.S.A.
Description
Qty.
Req.
ENGINE. . . . . . . . . . . . . . . . . . . . . 1
RELAY, ENGINE STARTER . . . . . . 1
WIRE ASY. (J. Deere eng.)
MOUNT, RELAY. . . . . . . . . . . . . . . 1
SENDER, WATER TEMP . . . . . . . . 1
FUEL LINE TUBE. . . . . . . . . . . . . . 1
HOSE, -6 K6/NONE 73” (Supply) . 1
HOSE, -4 K4/NONE 73” (Return) . 1
CLAMP, HOSE . . . . . . . . . . . . . . . 1
BRACKET, THROTTLE (JD). . . . . . 1
COUPLER, ROD-CABLE . . . . . . . . 1
ROD, THROTTLE EXTEND . . . . . . 1
BALL JOINT #10-32 ROD END . . . 1
5/8”-11X3-1/2” BOLT . . . . . . . . . . . 4
5/8”-11 NYLON INSERT NUT . . . . . 4
SENDER, OIL PRESSURE . . . . . . 1
ENGINE MOUNT (RIGHT) . . . . . . . 1
See note c
See note d
See note e
See note f
See note g
ENGINE MOUNT (LEFT) . . . . . . . . 1
See note c
See note d
See note e
See note f
See note g
M8X1.25X45M BOLT GR8 . . . . . . . 4
ADAP, M18 -6NPTF STR . . . . . . . . 2
SHUTOFF, MANUAL/WATER . . . . . 1
STEM, HOSE. . . . . . . . . . . . . . . . . 1
FAN BELT . . . . . . . . . . . . . . . . . . . 1
See note c (John Deere)
See note d and e (John Deere)
(Perkins)
ADAP, M18 10 BEAD STR . . . . . . . 1
BRACKET, ALTERNATOR . . . . . . . 1
Ref.
No.
Part
No.
00a
00h
L65570
L65568
L99978
L98600
L98602
Qty.
Req.
-- ITEMS NOT SHOWN -ENGINE BLOCK HEATER . . . . . . . 1
ENGINE BLOCK HEATER . . . . . . . 1
(Filters)
FUEL FILTER. . . . . . . . . . . . . . . . . 1
552: w/JD Engine S/N 1011 & Up
552: w/JD Engine Thru S/N 1010
With Perkins Engine.
L98601
OIL FILTER . . . . . . . . . . . . . . . . . . 1
553: w/JD Nat.Eng. S/N 3917 & Up
553: w/JD Turbo Eng S/N 3630 & Up
553: w/JD Nat. Eng Thru S/N 3916
553: w/JD Turbo Eng Thru S/N 3629
With Perkins Engine.
L66855
L66360
L68054
L650004
(Ether)
ETHER KIT . . . . . . . . . . . . . .
CANNISTER AND MOUNT . .
SWITCH, ROCKER (ETHER)
TERMINAL BLOCK . . . . . . . .
L99420
L94746
51
Description
a
Used with John Deere engines.
b
Replaces item 23 and (1) of item 21.
c
552: with J.D. Engine S/N 1021 & Up
553 with J.D. Turbo engine S/N 3630 & Up.
553 with J.D. Natural engine S/N 3917 & Up.
d
552: with J.D.Natural engine Thru S/N 1020
553 with J.D. Natural engine Thru S/N 3916.
e
552 with J.D. Turbo engine Thru S/N 1020
f
g
With Perkins 1004-4 Engine.
With Perkins 4.236 Engine.
h
Used with Perkins engines.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
908459/AP0603
Engine
552/553 Dynalift
Radiator and Cooler Group
6
25
7
1
9
6
2
4
8
5
3
19
4
24
5
21
23
22
12
11
4
10
13
3
18
14
17
19
10
5
4
16
15
4
20
FRONT
908459/AP0603
52
PRINTED IN U.S.A.
552/553 Dynalift
Engine
Radiator and Cooler Group
Ref.
No.
01
02
03
04
05
06
07h
08
09
10
11
12
13
14
15
16
17
18
19
20
Part
No.
L76084
L96989
L99433
L63356
L50141
L50228
L445001
L446020
L67452
L63400
L63399
L50230
L530004
L66119
L45934
L50151
L520019
L40805
L67589
L66515
L50815
L76020
L68580
L66414
L64047
L46881
L75020
21
22
L63665
L67751
L66709
PRINTED IN U.S.A.
Description
Qty.
Req.
HOSE CLAMP . . . . . . . . . . . . . . . . 1
RADIATOR CAP . . . . . . . . . . . . . . 1
See note a
See note b
COOLER MOUNT . . . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . 22
5/16”-18X1/2” BOLT . . . . . . . . . . . 10
ADAP, -12ORM -12JICM 90 DEG. . 2
ADAP -12JICFS -12JICM 90 DEG . 1
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-12 A12/DS12 135”)
See note b (-12 A12/DS12 76”)
HOSE -12 DS12/A12 82” . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . 12
5/16” NUT RETAINING CLIP . . . . . 4
COOLER/HEAT-EXCHANGER . . . . 1
RADIATOR. . . . . . . . . . . . . . . . . . . 1
1/2” FLAT WASHER . . . . . . . . . . . . 2
VALVE, DRAIN COCK . . . . . . . . . . 1
FAN SHROUD . . . . . . . . . . . . . . . . 1
See note c
See note d
5/16”X2-1/2” BOLT . . . . . . . . . . . . . 4
HOSE CLAMP . . . . . . . . . . . . . . . . 3
LOWER RADIATOR HOSE . . . . . . 1
See note e
See note f
See note g
CONNECTING TUBE . . . . . . . . . . 1
HOSE CLAMP . . . . . . . . . . . . . . . 4
FAN GUARD (HALF) . . . . . . . . . . . 2
Standard (Shown)
With Air Conditioning
FAN SPACER 1” . . . . . . . . . . . . . . 1
53
Ref.
No.
Part
No.
Description
Qty.
Req.
23
24
25
L66265
L47212
L68539
L68539
L61136
L64055
a
Modine and Raidator Specialites Radiators
(Refer to tag on radiator)
b
Indiana Heat Transfer Radiators
(Refer to tag on radiator)
c
Used With All J.D. Turbo Engines
552: with J.D. Natural Engine S/N 1021 & Up
d
553 with J.D. Natural engine Thru S/N 3629
552/553 with Perkins Engine
e
552: with J.D. Engine S/N 1021 & Up
553 with J.D. Turbo engine S/N 3630 & Up.
f
553 with J.D. Natural engine Thru S/N 3916.
g
Used with Perkins Engines
h
552: S/N 1015 and Up
553: S/N 3340 and Up
i
552: Thru S/N 1014
553: Thru S/N 3339
FAN, 18” . . . . . . . . . . . . . . . . . . . 1
VINYL CLAMP 3/8” HOSE . . . . . . . 2
UPPER RADIATOR HOSE . . . . . . . 1
See note e
See note f
See note g
908459/AP0603
Engine
552/553 Dynalift
Engine Air Intake Group
Pre-cleaner
(Optional)
9
8
7
6
5
4
3
2
1
10
11
12
FRONT
13
14
15
AIR CLEANER
Air Intake
Perkins
(Not Shown)
14
Air Intake
(Turbo Charged)
John Deere
14
16
ENGINE
18
19
17
14
17
Air Intake
(Natural Aspirated )
John Deere
ENGINE
AIR CLEANER
908459/AP0603
54
PRINTED IN U.S.A.
552/553 Dynalift
Engine
Engine Air Intake Group
Ref.
No.
Part
No.
L120038A
01
L98678
02
03
04
L98677
078936
L98647
L98649
L120054
L68516
L70468
L68517
L120039
L60291
NSS
L50230
L50056
L67657
L51099
L120041
L63439
L66877
05
06
07
08
09
10
11
12
13a
14a
15a
16b
17b
18b
L68643
PRINTED IN U.S.A.
Description
Qty.
Req.
AIR CLEANER ASSEMBLY . . . . . . 1
(Includes items 1-5, and 10)
DUST CUP ASSEMBLY . . . . . . . . . 1
(Includes item 2) . . . . . . . . . . . . . . .
BAFFLE (Included with item 1) . . . . 1
WING NUT. . . . . . . . . . . . . . . . . . . 1
TIGHTENING CLAMP . . . . . . . . . . 1
THUMBSCREW . . . . . . . . . . . . . . 1
ELEMENT . . . . . . . . . . . . . . . . . . . 1
PRE-CLEANER (Optional) . . . . . . . 1
4” T-BOLT BAND CLAMP . . . . . . . 1
REDUCER, RUBBER 4”-3” . . . . . . 1
BAND, FILTER MOUNTING . . . . . . 2
AIR INTAKE CAP (Standard) . . . . . 1
AIR CLEANER BODY . . . . . . . . . . 1
5/16”-18X3/4” BOLT . . . . . . . . . . . . 4
5/16”-18 FLANGE NUT . . . . . . . . . 4
ELBOW, METAL 3” . . . . . . . . . . . . 1
CLAMP, HOSE SAE #52 . . . . . . . . 5
ELBOW, RUBBER 3”ID . . . . . . . . . 2
ELBOW, RUBBER 2-1/2” ID . . . . . 1
CLAMP, HOSE SAE #44 . . . . . . . . 3
AIR INTAKE PIPE 2-1/2” OD . . . . . 1
See note c
55
Ref.
No.
Part
No.
19b
L67607
L63764
L64788
Description
Qty.
Req.
See note d
See note e
ELBOW, RUBBER 3”IDX2-1/2” ID . 1
-- ITEMS NOT SHOWN -(PERKINS - AIR INTAKE)
AIR INTAKE PIPE . . . . . . . . . . . . . 1
ELBOW, RUBBER 3”ID . . . . . . . . . 1
(attaches to air cleaner & intake pipe)
ELBOM, RUBBER . . . . . . . . . . . . . 1
(attaches to air intake pipe & engine)
HOSE CLAMP . . . . . . . . . . . . . . . . 3
HOSE CLAMP . . . . . . . . . . . . . . . . 1
00
00
L63551
L120041
00
L63439
00
00
L51674
L51098
a
b
Used on John Deere turbo equipped engine.
Used on John Deere natural aspirated engine.
c
552: S/N 1021 & Up
553: S/N 3917 & Up
d
552: S/N 1015 - 1020
553: S/N 3340 - 3916
e
552: Thru S/N 1014
553: Thru S/N 3339
908459/AP0603
Engine
552/553 Dynalift
Engine Exhaust Group
1
3
2
Engine Exhaust Pipes
(Perkins Not Shown)
4
5
6
9
7
11
8
12
JD Turbo
JD Natural
10
13
Engine Exhaust
Perkins
(Not Shown)
14
15
8
2
Muffler Bracket
(JD Turbo)
20
19
2
17
18
5
16
FRONT
908459/AP0603
56
PRINTED IN U.S.A.
552/553 Dynalift
Engine
Engine Exhaust Group
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09a
10a
11b
L68529
L67617
L63636
L67626
L520005
L48011
L120047
L64764
L50145
L50367
L50952
L500314
L500315
L68651
L500314
L63650
L66595
L120047
L99434
L98726
12b
13b
14
L68544
L65025
L60492
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
TAILPIPE . . . . . . . . . . . . . . . . . . . . 1
Note g (2-1/2” OD)
Note a & c (2-1/4” OD)
Note a & c (Before 10/93 production)
Note e
MUFFLER CLAMP . . . . . . . . . . . . . 1
Note a (2-1/4” CLAMP)
Note b (2-1/2” CLAMP)
TAILPIPE HANGER . . . . . . . . . . . . 1
3/8” FLAT WASHER . . . . . . . . . . . . 5
3/8”-16X1” BOLT . . . . . . . . . . . . . . 1
M10 1.5X25mm BOLT . . . . . . . . . . 4
EXHAUST GASKET . . . . . . . . . . . 1
M12 1.75X39mm BOLT . . . . . . . . . 2
EXHAUST PIPE (JD Natural) . . . . . 1
Note f
Gasket (4 bolt holes)
Note d
Gasket
2-1/2” MUFFLER CLAMP . . . . . . . . 1
TURBO CLAMP . . . . . . . . . . . . . . . 1
Note g (553: S/N 3630 & Up)
Note e
EXHAUST PIPE (JD Turbo) . . . . . . 1
Note g (553: S/N 3630 & Up)
Note e
3” MUFFLER CLAMP. . . . . . . . . . . 1
MUFFLER CLAMP
Part
No.
L120047
L60492
15
16
17
18
19b
20b
L63660
L64821
L50442
L67756
L50836
L61021
L64572
00
L63919
Qty.
Req.
Note a & note c (2-1/2” CLAMP)
Note b (3” CLAMP)
MUFFLER . . . . . . . . . . . . . . . . . . . 1
See note a and note c
See note b
3/8”-16X1-1/4” SELF TAP BOLT . . . 4
MUFFLER GUARD . . . . . . . . . . . . 1
3/8”-16X1-3/4” BOLT . . . . . . . . . . . 1
MUFFLER STRAP . . . . . . . . . . . . . 1
MUFFLER BRACKET. . . . . . . . . . . 1
-- ITEMS NOT SHOWN -HEAT SHIELD . . . . . . . . . . . . . . . . 1
(Units with heat shield on tailpipe)
00
00
(PERKINS - ENGINE EXHAUST)
L63664
EXHAUST PIPE . . . . . . . . . . . . . . . 1
(attch. muffler & exh. manifold pipe)
L63648
EXHAUST MANIFOLD PIPE . . . . . 1
(attaches to exhaust manifold)
L48011
MUFFLER CLAMP 2-1/4” . . . . . . . . 1
L120047
MUFFLER CLAMP 2-1/2” . . . . . . . . 1
a
b
c
d
e
f
g
Used with John Deere natural aspirated engine.
Used with John Deere turbo charged engine.
Used with Perkins engine.
John Deere 4039 Natural Engine
John Deere 4039T Turbo Engine
John Deere 4045 Natural Engine
John Deere 4045T Turbo Engine.
00
00
57
Description
908459/AP0603
Transmission
552/553 Dynalift
External Components and Driveshaft Group
1
2
3
4
26
25
27
24
6
5
12
FRONT
7
9
8
23
22
20
11
21
12
17
10
18
19
10
16
15
10
14
13
REAR
908459/AP0603
58
PRINTED IN U.S.A.
552/553 Dynalift
Transmission
External Components and Driveshaft Group
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L63633
L42342
L50609
L47275
L50367
L50056
L63399
L444001
L66965
L444007
L67452
L444070
L68588
L68562
L63202
L63129
10a
11
12
13
14
15
16
17
L50468
L50319
L50704
L520007
L64197
L64124
L64196
L68533
L67575
L63264
18
L68296
L66917
19
L68563
L63203
L63078
20
21b
Note e
L10151
650965
Description
Qty.
Req.
Ref.
No.
PARK BRAKE CABLE . . . . . . . . . . 1
CLEVIS PIN . . . . . . . . . . . . . . . . . 2
COTTER PIN . . . . . . . . . . . . . . . . 2
CABLE CLAMP. . . . . . . . . . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . 1
3/8”-16 FLANGE NUT . . . . . . . . . . 1
HOSE -12 A12/DS12 82” . . . . . . . . 1
ADAP, -12ORM -12JICM STR . . . . 1
SENDER, TEMP 250 DEGREE . . . 1
ADAP, -10ORM -12JICM STR . . . . 1
HOSE -12 DS12/A12 135” . . . . . . . 1
ADAP, -3ORM . . . . . . . . . . . . . . . . 1
SWITCH, PRESSURE . . . . . . . . . . 1
DRIVESHAFT, FRONT. . . . . . . . . . 1
553 Only; S/N 3630 & Up.
553 Only; S/N 3126-3355.
552: S/N 1001 & Up
553: S/N 3001-3125 & 3356-3629.
3/8”-24X1-3/4” GR8 BOLT . . . . . . 16
5/8”-11X3-1/2” BOLT . . . . . . . . . . . 2
M12X1.75X40mm BOLT. . . . . . . . . 4
5/8”-11 NYLON INSERT NUT . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . 2
TRANS MOUNT, RIGHT . . . . . . . . 1
Note f
Note g
Note h
TRANSMISSION,T12000 . . . . . . . . 1
Used with turbo engine
Used with natural engine
DRIVESHAFT, REAR . . . . . . . . . . . 1
553 Only; S/N 3630 & Up.
553 Only; S/N 3126-3355.
552: S/N 1001 & Up
553: S/N 3001-3125 & 3356-3629.
UNIVERSAL JOINT . . . . . . . . . . . . 4
GREASE ZERK . . . . . . . . . . . . . . 2
3/8”-24X1-1/4” GR 8 BOLT . . . . . . . 8
22c
23
24
25
26d
27
a
b
c
d
Part
No.
L50147
L50833
L68531
L67574
L63263
L71637
L50952
L50727
L99184
Description
Qty.
Req.
3/8” LOCK WASHER. . . . . . . . . . . 8
3/8”-24X2” GRADE 8 BOLT . . . . . . 8
TRANS MOUNT, LEFT. . . . . . . . . . 1
Note f
Note g
Note h
BRACKET, PARK BRAKE . . . . . . . 1
M10X1.5X25mm. . . . . . . . . . . . . . 10
M10X1.5X35mm . . . . . . . . . . . . . . 2
FILTER, TRANSMISSION OIL . . . . 1
Used to fasten universal joint to transmission
and to axle yokes.
Used to fasten universal joint to driveshaft.
Used to fasten flex plate to flywheel.
Used to fasten throttle bracket to transmission
e
L99182 - 5C Non-Greaseable, directly interchange
able w/L98555 except is non-greaseable,
has tapped Bearing Cans for mounting to Shaft.
552: S/N 1008 & Up.
553: S/N 3356 & Up.
L99076 - 5C Lube-For-Life has through-hole
Bearing Cans for mounting to tapped shaft.
552: S/N Not Available.
553: S/N 3126 thru 3355.
L98555 - 5C Greaseable, has tapped Bearing Caps
for mounting to Shaft.
552: S/N 1001 thru 1007.
553: S/N 3001 thru 3125.
f
552: S/N 1021 & Up
553: S/N 3630 & Up
g
552: Used w/J.D. Turbo engine Thru S/N 1020
553: Used w/J.D. Turbo engine Thru S/N 3629
h
552: Used w/J.D. Natural engine Thru S/N 1020
553: Used w/J.D. Natural engine Thru S/N 3629
HOSE LOCATOR
02
06
TRANSIMISSION (RIGHT SIDE)
TRANSIMISSION (LEFT SIDE)
PRINTED IN U.S.A.
OIL COOLER (LEFT SIDE)
OIL COOLER (RIGHT SIDE)
59
908459/AP0603
Transmission
552/553 Dynalift
Internal Components
NOTICE
FOR INTERNAL PARTS BREAKDOWN OF
THE 12000 SERIES TRANSMISSION,
REFER TO SEPERATE
MANUAL FORM 907368.
IF YOU DO NOT HAVE THIS MANUAL, IT
CAN BE ORDERED BY CALLING
SERVICE PARTS AT (605)665-6500.
908459/AP0603
60
PRINTED IN U.S.A.
552/553 Dynalift
Transmission
Notes
PRINTED IN U.S.A.
61
908459/AP0603
Axles
552/553 Dynalift
External Components
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
To Brake Master
Cylinder
6
4
1
REAR
7
5
3
BRAKE LINES
2
10
11
9
8
12
14
15
13
STEERING LINES
16
17
27
26
FRONT AXLE
(SHOWN)
25
18
19
FRONT
24
21 20
23
22
AXLE SUPPORT
908459/AP0603
62
PRINTED IN U.S.A.
552/553 Dynalift
Axles
External Components
(552: S/N 1075 and Up ; 553: S/N 4832 and Up)
Ref.
No.
Part
No.
Description
Qty.
Req.
NOTE: All quantities are per axle.
01
02a
03a
04a
05
06
07
08
09
10a
11
L68849
L68878
L50157
L50084
P471370
L63382
L63381
L60653
L66139
651543
L500546
12
13
L500540
L500539
L500541
14
15
100011
L63386
AXLE, MODEL 212/233 . . . . . . . .
FRAME LEVEL MOUNT. . . . . . . .
3/4” WASHER, FLAT . . . . . . . . . .
3/4”-10 STOVER LOCK NUT . . . .
ADAP, -6JICM -6JICFS TEE. . . . .
HOSE, -4 A4/DS6 88”. . . . . . . . . .
HOSE, -4A6/A6 15” . . . . . . . . . . .
ADAP, -6JICFS -6JICM 90 DEG . .
ADAP, M14ORM -6JICM STR . . .
M20X2.5X130mm C10 BOLT . . . .
ARTICULATED TIE ROD W/NUT .
(Right Front, Left Rear)
STEER CYLINDER . . . . . . . . . . .
STEER CYLINDER BOLT . . . . . .
ARTICULATED TIE ROD W/NUT .
(Left Front, Right Rear)
ADAP, M18ORM -8JICM STR . . .
HOSE, -6 A8/A6 36” . . . . . . . . . . .
(front axle right side)
HOSE, -6 A8/DS6 110” . . . . . . . . .
(rear axle right side)
HOSE, -6 A8/DS8 67”. . . . . . . . . .
(front axle left side)
HOSE, -6 A8/DS6 100”. . . . . . . . .
(rear axle left side)
ADAP, -8JICFS -8JICM 90 DEG . .
L63403
16
L63387
L63388
17
L446017
.
.
.
.
.
.
.
.
.
.
.
2
1
4
4
1
1
1
1
2
4
1
.1
.4
.1
.2
.1
Ref.
No.
Part
No.
Description
18
19
L69734
Qty.
Req.
L63222
L45049
L68875
M22X1.5 WHEEL NUT . . . . . . . . 16
TIRE AND WHEEL ASY . . . . . . . AR
VALVE STEM . . . . . . . . . . . . . . . . . 1
TIRE, 15.00X19.5 12 PLY . . . . . . . 1
WHEEL ONLY (for tire L45049) . . . 1
L67499
L68884
TIRE, 405/70R 20XM27 . . . . . . . . . 1
L67502
L67504
TIRE, 9.00R 20XMINE D2 . . . . . . . 1
20
21
22
23
24
25
26
27a
L500543
L500544
L500490
L98355
L500542
L50201
L50712
L68876
THRUST BUSHING . . . . . . . . . . . . 2
SUPPORT . . . . . . . . . . . . . . . . . . . 2
PLUG. . . . . . . . . . . . . . . . . . . . . . . 2
GREASE FITTING . . . . . . . . . . . . . 2
REDUCTION BUSHING . . . . . . . . . 2
M20X2.5 NYL. LOCK NUT C10 . . . 4
3/4”-10X9” GR8 BOLT . . . . . . . . . . 4
PLATE, FRAME LEVEL . . . . . . . . . 1
a
Used only on front axle.
.1
.1
.1
.2
HOSE LOCATOR
15
16
STEER
STEER
STEER
STEER
CYLINDER,
CYLINDER,
CYLINDER,
CYLINDER,
PRINTED IN U.S.A.
FRONT AXLE RIGHT SIDE
REAR AXLE RIGHT SIDE
FRONT AXLE LEFT SIDE
REAR AXLE LEFT SIDE
STEER
STEER
STEER
STEER
63
SELECT VALVE PORT “T”
SELECT VALVE PORT “B”
MOTOR PORT “L”
SELECT VALVE PORT “A”
908459/AP0603
Axles
552/553 Dynalift
External Components
(552: Thru S/N 1074; 553: Thru S/N 4831)
6
To Brake Master
Cylinder
BRAKE LINES
7
5
4
3
1
8
2
12
11
10
9
STEERING LINES
14
15
13
9
16
20
11
10
18
19
FRONT AXLE
(SHOWN)
17
FRONT
908459/AP0603
64
PRINTED IN U.S.A.
552/553 Dynalift
Axles
External Components
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
02a
03a
04a
05
06
07
08
09b
10
11
12
13
14
L63234
L63009
L50157
L50084
L446049
L63382
L63381
L66139
L98443
L99969
L98422
L63280
L63943
L63114
L50462
L520019
L98444
L98445
L98565
L98430
L63386
AXLE, ASSEMBLY . . . . . . . . . . . . . 2
FRAME LEVEL MOUNT. . . . . . . . . 1
3/4” WASHER, FLAT . . . . . . . . . . . 4
3/4”-10 STOVER LOCK NUT . . . . . 4
ADAP, -6JICM -6JICFS SVL TEE . . 1
HOSE, -4 A4/DS6 88”. . . . . . . . . . . 1
HOSE, -4A6/A6 15” . . . . . . . . . . . . 1
ADAP, M14ORM -6JICM STR . . . . 2
ARTICULATED TIE ROD W/NUT . . 2
TIE ROD NUT . . . . . . . . . . . . . . . . 2
THRUST BUSHING . . . . . . . . . . . . 2
THRUST WASHER, THICK . . . . . . 2
THRUST WASHER, THIN . . . . . . . 2
AXLE PIVOT PIN . . . . . . . . . . . . . . 1
1/2”-13X5” BOLT . . . . . . . . . . . . . . 1
1/2”-13 NYLON INSERT NUT . . . . 1
STEER CYLINDER ASSEMBLY . . . 1
CYLINDER BOLT . . . . . . . . . . . . . 5
SEAL KIT . . . . . . . . . . . . . . . . . . . 1
VENT BOLT . . . . . . . . . . . . . . . . . 1
HOSE, -6 A8/A6 36” . . . . . . . . . . . . 1
(front axle right side)
HOSE, -6 A8/DS6 110” . . . . . . . . . . 1
(rear axle right side)
HOSE, -6 A8/DS8 67”. . . . . . . . . . . 1
(front axle left side)
HOSE, -6 A8/DS6 100”. . . . . . . . . . 1
(rear axle left side)
ADAP, 18X1.5ORM -8JICM 90D. . . 2
L63403
15
L63387
L63388
16
L66138
Ref.
No.
Part
No.
17
18
L98345
19
20a
Description
Qty.
Req.
L63222
L45049
L63044
WHEEL NUT . . . . . . . . . . . . . . . . 16
WHEEL & TIRE . . . . . . . . . . . . . . AR
VALVE STEM . . . . . . . . . . . . . . . . . 1
TIRE, 15-19.5 12 PLY . . . . . . . . . . 1
WHEEL (FOR L45049 TIRE) . . . . . 1
L67499
L67498
TIRE, 405/70 R20 . . . . . . . . . . . . . 1
WHEEL(FOR L67499 TIRE) . . . . . 1
L67502
L67504
L67507
L67508
L50712
L63115
TIRE, 9.00XR20XMINE D2 . . . . . . .1
WHEEL (FOR L67502 TIRE) . . . . . 1
FLAP . . . . . . . . . . . . . . . . . . . . . . . 1
TUBE. . . . . . . . . . . . . . . . . . . . . . . 1
3/4”-10X9” GR8 BOLT . . . . . . . . . . 4
MOUNT PLATE . . . . . . . . . . . . . . . 1
a
Used on front axle only.
b
The left and right side use the same tie rod, the
tie rod ends are not sold seperately.
HOSE LOCATOR
14
15
STEER
STEER
STEER
STEER
CYLINDER,
CYLINDER,
CYLINDER,
CYLINDER,
PRINTED IN U.S.A.
FRONT AXLE RIGHT SIDE
REAR AXLE RIGHT SIDE
FRONT AXLE LEFT SIDE
REAR AXLE LEFT SIDE
STEER
STEER
STEER
STEER
65
MOTOR PORT “L”
908459/AP0603
Axles
552/553 Dynalift
Outer End Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
FRONT
5
3
4
1
2
25
13
14 8
15 47 7
16
6
17
9
10
49
12
24
19
21,26
27
28
29
20
1
19
45
44
48
13
23
30
31
2
22
11
28
32
18
33
16
46
15
34
35
36
50
43
37
38
41
42
40
908459/AP0603
66
39
25
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Outer End Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
02
03
04
05
L500483
L500484
L500485
L500486
L500488
06
07
07
09
10
11
L500489
L98371
L98372
L500490
L500491
L500492
12
13
14
15
16
17
L500493
L500494
L500495
L500496
L98355
L500497
18
L500498
19
20
21
L500499
L500500
L500501
22
23
24
L500502
L500503
L500456
PRINTED IN U.S.A.
NUT . . . . . . . . . . . . . . . . . . . . . . . . 2
STEERING ADJUST BOLT. . . . . . . 2
AXLE CASE. . . . . . . . . . . . . . . . . . 2
BOLT . . . . . . . . . . . . . . . . . . . . . . 32
REDUCTION BUSHING . . . . . . . . . 2
(includes items 6-9, and 47)
SEAL . . . . . . . . . . . . . . . . . . . . . . . 2
BALL BEARING . . . . . . . . . . . . . . . 2
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . 2
JOINT . . . . . . . . . . . . . . . . . . . . . . 2
THRUST BUSHING . . . . . . . . . . . . 2
(included with items 21 and 26)
OUTER RACE . . . . . . . . . . . . . . . . 2
BOLT . . . . . . . . . . . . . . . . . . . . . . 20
COVER . . . . . . . . . . . . . . . . . . . . . 2
PLUG. . . . . . . . . . . . . . . . . . . . . . . 4
GREASE FITTING . . . . . . . . . . . . . 2
PIVOT PIN . . . . . . . . . . . . . . . . . . . 2
(includes item 16)
PIVOT PIN . . . . . . . . . . . . . . . . . . . 2
(includes items 16, 19 and 20)
SEAL . . . . . . . . . . . . . . . . . . . . . . . 2
ARTICULATION . . . . . . . . . . . . . . . 2
STEERING CASE - LF/RR . . . . . . . 1
(includes item 11)
SEAL . . . . . . . . . . . . . . . . . . . . . . . 2
DUST EXCLUDER . . . . . . . . . . . . . 2
MAGNETIC PLUG . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
25
26
L98318
L500504
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
L500505
L500506
L500507
L500508
L98417
L500509
L500510
L500511
L500512
L500513
L69734
L500455
L500515
L500516
L500517
L500518
L500519
L500554
L500521
L500522
L98373
L500555
L500523
L500524
L500525
L500526
50
67
Description
Qty.
Req.
PLUG. . . . . . . . . . . . . . . . . . . . . . . 4
STEERING CASE - RF/LR . . . . . . . 1
(includes item 11)
SEAL . . . . . . . . . . . . . . . . . . . . . . . 2
BEARING. . . . . . . . . . . . . . . . . . . . 4
WHEEL STUD . . . . . . . . . . . . . . . 16
WHEEL HUB . . . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . 2
RING GEAR. . . . . . . . . . . . . . . . . . 2
RING GEAR SUPPORT . . . . . . . . . 2
CIRCLIP . . . . . . . . . . . . . . . . . . . . 8
PLANET GEAR . . . . . . . . . . . . . . . 8
BEARING. . . . . . . . . . . . . . . . . . . . 8
WHEEL NUT . . . . . . . . . . . . . . . . 16
SEAL WASHER . . . . . . . . . . . . . . . 6
COUNTERSUNK BOLT . . . . . . . . . 4
PLANET GEAT CARRIER . . . . . . . 2
STUD. . . . . . . . . . . . . . . . . . . . . . 16
NUT . . . . . . . . . . . . . . . . . . . . . . . 16
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
ADJUSTING BOLT. . . . . . . . . . . . . 4
NUT . . . . . . . . . . . . . . . . . . . . . . . . 4
LOCKING PLATE . . . . . . . . . . . . . . 2
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
SPACER . . . . . . . . . . . . . . . . . . . . 2
SHIM - .15mm . . . . . . . . . . . . . . . . 2
SHIM - .20mm . . . . . . . . . . . . . . . . 2
SHIM - .50mm . . . . . . . . . . . . . . . . 2
PLANET GEAR CARRIER . . . . . . . 2
(includes items 32-36, 40-41)
908459/AP0603
Axles
552/553 Dynalift
Outer End Group - Part I
(552: Thru S/N 1074; 553: Thru S/N 4831)
5
24
4
1
6
7
2
8
9
22
10
21
20
16
14
15
11
3
23
10
19
9
4
8
18
17
5
13
24
908459/AP0603
12
68
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Outer End Group - Part I
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
01
02
03
04
05
06
07
08
09
10
L98352
L98353
L98997
L98375
L98998
L98354
L98355
L98377
L98356
L98360
L98361
L97134
11
12
13
14
15
16
CASE. . . . . . . . . . . . . . . . . . . . . . . 2
GRUB BOLT . . . . . . . . . . . . . . . . . 2
NUT . . . . . . . . . . . . . . . . . . . . . . . . 2
STUD. . . . . . . . . . . . . . . . . . . . . . 24
NUT . . . . . . . . . . . . . . . . . . . . . . . 24
PIVOT PIN . . . . . . . . . . . . . . . . . . . 4
GREASE ZERK . . . . . . . . . . . . . . . 4
STUD. . . . . . . . . . . . . . . . . . . . . . . 4
SHIM - PACK . . . . . . . . . . . . . . . . . 2
DUST EXCLUDER . . . . . . . . . . . . . 4
RING . . . . . . . . . . . . . . . . . . . . . . . 4
TAPER ROLLER BRG
CONE . . . . . . . . . . . . . . . . . . . . . . 4
17
18
19
20
21
22
23
24
PRINTED IN U.S.A.
69
Part
No.
L97135
L98376
L98363
L98364
L98365
L98366
L98367
L99188
L98368
L98370
L98369
L98371
L98372
L98373
L98374
L98996
L99639
Description
Qty.
Req.
CUP. . . . . . . . . . . . . . . . . . . . . . . . 4
PLUG. . . . . . . . . . . . . . . . . . . . . . . 2
NEEDLE BRG . . . . . . . . . . . . . . . . 2
SNAP RING . . . . . . . . . . . . . . . . . . 2
SEAL, OUTER . . . . . . . . . . . . . . . . 2
DUST EXCLUDER . . . . . . . . . . . . . 2
DOUBLE UNIVERSAL JOINT . . . . 2
U-JOINT CROSS ONLY . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . 2
REDUCER BUSHING . . . . . . . . . . 2
SEAL, INNER. . . . . . . . . . . . . . . . . 2
BALL BRG.. . . . . . . . . . . . . . . . . . . 2
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
STUD. . . . . . . . . . . . . . . . . . . . . . . 4
NUT . . . . . . . . . . . . . . . . . . . . . . . 4
HEX BOLT . . . . . . . . . . . . . . . . . . 24
908459/AP0603
Axles
552/553 Dynalift
Outer End Group - Part II
(552: Thru S/N 1074; 553: Thru S/N 4831)
5
2
1
7
3
8
17
10
11
14
18
12
13
15
22
27
24
4
23
3
6
9
16
28
29
26
25
19
20
21
20
30
908459/AP0603
70
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Outer End Group - Part II
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
L98338
L98339
L98341
L98973
L98342
L98343
L98344
L98345
L98346
L98347
L98348
L98349
L98350
L98331
PRINTED IN U.S.A.
O-RING . . . . . . . . . . . . . . . . . . . . . 2
SEAL . . . . . . . . . . . . . . . . . . . . . . . 2
TAPER ROLLER BRG . . . . . . . . . . 4
SPACER . . . . . . . . . . . . . . . . . . . . 2
WHEEL STUD . . . . . . . . . . . . . . . 16
WHEEL HUB . . . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . 2
WHEEL NUT . . . . . . . . . . . . . . . . 16
SNAP RING . . . . . . . . . . . . . . . . . . 2
RING GEAR SUPPORT . . . . . . . . . 2
DOWEL . . . . . . . . . . . . . . . . . . . . . 8
LOCKING PLATE . . . . . . . . . . . . . . 2
PINION . . . . . . . . . . . . . . . . . . . . . 2
RING GEAR. . . . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
15
16
17
18
19
20
21
22
23
24
25
26
27
L98332
L98324
L98325
L98333
L98323
L98321
L98322
L98334
L98318
L98335
L98319
L98320
28
29
30
71
L98336
L98337
L98972
L99213
L99203
Description
Qty.
Req.
CIRCLIP . . . . . . . . . . . . . . . . . . . . 2
FRICTION WASHER . . . . . . . . . . . 2
SHIM-PAC . . . . . . . . . . . . . . . . . . . 1
FRICTION WASHER . . . . . . . . . . . 2
FRICTION WASHER . . . . . . . . . . . 6
NEEDLE BRG. . . . . . . . . . . . . . . 12
PLANET GEAR . . . . . . . . . . . . . . . 6
PLANET GEAR CARRIER . . . . . . . 2
PLUG, 12MM (Socket Head) . . . . . 2
SEAL WASHER . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . 6
PIN . . . . . . . . . . . . . . . . . . . . . . . . 6
CASE KNUCKLE . . . . . . . . . . . . . . .
RIGHT FRONT / LEFT REAR. . . . . 1
LEFT FRONT / RIGHT REAR. . . . . 1
STUD. . . . . . . . . . . . . . . . . . . . . . . 8
BOLT . . . . . . . . . . . . . . . . . . . . . . . 8
SPACER . . . . . . . . . . . . . . . . . . . . 6
908459/AP0603
Axles
552/553 Dynalift
Differential Housing Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
2
3
4
5
6
7
1
8
6
1
1
908459/AP0603
72
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Differential Housing Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
Ref.
No.
01
02
03
Part
No.
Description
Qty.
Req.
L98417
O-RING . . . . . . . . . . . . . . . . . . . . . 3
L500451
INTERMEDIATE COVER . . . . . . . . 1
L500452
HOUSING . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
73
Ref.
No.
Part
No.
04
05
06
07
08
L500453
L500454
L500455
L98318
L500456
Description
COVER . . . . . . . . .
VENT. . . . . . . . . . .
SEAL WASHER . . .
PLUG. . . . . . . . . . .
MAGNETIC PLUG .
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
1
1
908459/AP0603
Axles
552/553 Dynalift
Differential Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
7
8
24
12
13
11
10
14
6
12
24
5
4
11
9
11
12
16
15
24
3
18
13
4
13
16
20
12
24
21
7
13
14
11
9
22
5
1
17
2
23
908459/AP0603
19
74
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Differential Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
Description
Qty.
Req.
L500457
O-RING . . . . . . . . . . . . . . . . . . . . . 1
L500458
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
L500459
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
L500460
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
L500461
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
L500462
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
L500463
BEVEL GEAR SET. . . . . . . . . . . . . 1
L98380
TAPER ROLLER BEARING . . . . . . 2
L500464
RING NUT . . . . . . . . . . . . . . . . . . . 2
L500465
CYLINDER BOLT . . . . . . . . . . . . . . 4
L500466
CYLINDER BOLT . . . . . . . . . . . . . . 2
L500467
BOLT . . . . . . . . . . . . . . . . . . . . . . 12
L500468
FRICTION WASHER . . . . . . . . . . . 2
L500469
DIFFERENTIAL SIDE GEAR . . . . . 2
L500470
PIN . . . . . . . . . . . . . . . . . . . . . . . . 4
PRINTED IN U.S.A.
Ref.
No.
Part
No.
12
13
14
15
16
17
L500471
L500472
L500473
L500474
L500771
L98404
L98406
L500476
L500477
L500478
L98396
L98395
L98394
L500479
L500480
L500481
18
19
20
21
22
23
24
75
Description
Qty.
Req.
CIRCLIP . . . . . . . . . . . . . . . . . . . . 4
FRICTION WASHER . . . . . . . . . . . 4
DIFFERENTIAL PINION . . . . . . . . . 4
DIFFERENTIAL CARRIER . . . . . . . 1
TAPER ROLLER BEARING . . . . . . 2
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
SHIM . . . . . . . . . . . . . . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . 1
RING NUT . . . . . . . . . . . . . . . . . . . 1
SEAL . . . . . . . . . . . . . . . . . . . . . . . 1
COVERPLATE . . . . . . . . . . . . . . . . 1
FLANGE . . . . . . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . 1
CIRCLIP . . . . . . . . . . . . . . . . . . . . 4
908459/AP0603
Axles
552/553 Dynalift
Differential Housing Group - Part I
(552: Thru S/N 1074; 553: Thru S/N 4831)
1
2
3
CASE
(SEE PART III)
5
6
4
8
5
HOUSING
(SEE PART III)
13
7
14
9
10
11
12
908459/AP0603
76
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Differential Housing Group - Part I
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
02
03
04
05
06
L98378
L98379
L98380
L98381
L500771
L98404
L98405
L98406
L98407
PRINTED IN U.S.A.
Ref.
No.
Part
No.
07
L98414
L98415
L98400
L98401
L98396
L98395
L98394
L98393
L98392
L98391
08
SHEET. . . . . . . . . . . . . . . . . . . . . . 2
RING NUT . . . . . . . . . . . . . . . . . . . 2
TAPERED ROLLER BRG. . . . . . . . 2
BEVEL GEAR SET. . . . . . . . . . . . . 1
TAPER ROLLER BRG. . . . . . . . . . . 2
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
09
10
11
12
13
14
77
Description
Qty.
Req.
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
SHIM. . . . . . . . . . . . . . . . . . . . . . AR
SPACER . . . . . . . . . . . . . . . . . . . . 1
SPACER . . . . . . . . . . . . . . . . . . . . 1
RING NUT . . . . . . . . . . . . . . . . . . . 1
SEAL . . . . . . . . . . . . . . . . . . . . . . . 1
COVER PLATE . . . . . . . . . . . . . . . 1
FLANGE . . . . . . . . . . . . . . . . . . . . 1
O-RING . . . . . . . . . . . . . . . . . . . . . 1
NUT . . . . . . . . . . . . . . . . . . . . . . . . 1
908459/AP0603
Axles
552/553 Dynalift
Differential Housing Group - Part II
(552: Thru S/N 1074; 553: Thru S/N 4831)
16
17
HOUSING
(SEE PART III)
15
13
7
8
6
10
9
5
11
14
6
4
3
11
5
9
10
8
2
12
8
908459/AP0603
78
1
CASE
(SEE PART III)
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Differential Housing Group - Part II
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
01
02
03
04
05
06
07
08
L98378
L98379
L98380
L98388
L98382
L98383
L98381
L98386
PRINTED IN U.S.A.
SHEET. . . . . . . . . . . . . . .
RING NUT . . . . . . . . . . . .
TAPERED ROLLER BRG.
COVER . . . . . . . . . . . . . .
DISK . . . . . . . . . . . . . . . .
DIFF. SIDE GEAR . . . . . .
BEVEL GEAR SET. . . . . .
ROLL PIN . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
2
1
2
2
1
3
Ref.
No.
Part
No.
09
10
11
12
13
14
15
L98385
L98384
L98387
L98389
L98390
L98416
L500317
L500356
L64326
L277013
16
17
79
Description
Qty.
Req.
PIN . . . . . . . . . . . . . . . . . . . . . . . . 2
DISK . . . . . . . . . . . . . . . . . . . . . . . 4
DIFF. PINION . . . . . . . . . . . . . . . . . 4
PIN . . . . . . . . . . . . . . . . . . . . . . . . 1
DIFF. CASE . . . . . . . . . . . . . . . . . . 1
RETAINER . . . . . . . . . . . . . . . . . . . 1
BOLT . . . . . . . . . . . . . . . . . . . . . . 16
SPRING WASHER . . . . . . . . . . . 16
HOSE . . . . . . . . . . . . . . . . . . . . . . 2
GREASE ZERK . . . . . . . . . . . . . . . 2
908459/AP0603
Axles
552/553 Dynalift
Differential Housing Group - Part III
(552: Thru S/N 1074; 553: Thru S/N 4831)
2
3
1
6
4
11
2
10
5
9
12
1
9
2
6
8
5
2
7
9
908459/AP0603
80
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Differential Housing Group - Part III
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
06
07
08
09
10
11
12
L98422
L98427
L98428
L98425
L98423
L98424
L98426
01
02
03
04
05
L98418
L98417
L98419
L98420
L98421
PRINTED IN U.S.A.
CASE. .
O-RING
PLUG. .
PLUG. .
O-RING
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
4
1
1
2
81
Description
THRUST BUSHING .
ADAPTER . . . . . . . .
HOUSING . . . . . . . .
MAGNETIC PLUG . .
CIRCLIP . . . . . . . . .
COVER . . . . . . . . . .
VENT. . . . . . . . . . . .
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
1
3
1
1
1
908459/AP0603
Axles
552/553 Dynalift
Brake Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
10
2
3
1
4
5
12
14
11
6
7
9
8
13
908459/AP0603
82
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Brake Group
(552: S/N 1075 and Up; 553: S/N 4832 and Up)
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
.
07
08
09
10
11
12
13
14
L500533
L500534
L500535
L500536
L98430
L500496
L500537
L500538
01
02
03
04
05
06
L500527
L500528
L500529
NSS
L500531
L500532
PRINTED IN U.S.A.
BRAKE DISC . . . . .
ADJUSTING BOLT.
SPRING. . . . . . . . .
PISTON . . . . . . . . .
SPRING. . . . . . . . .
BACK-UP RING . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
6
6
6
2
6
2
83
Description
Qty.
Req.
O-RING . . . . . . . . . . . . . . . . . . . . . 2
BACK-UP RING . . . . . . . . . . . . . . . 2
O-RING . . . . . . . . . . . . . . . . . . . . . 2
INTERMEDIATE BRAKE DISC. . . . 8
BLEEDING BOLT . . . . . . . . . . . . . . 2
PLUG. . . . . . . . . . . . . . . . . . . . . . . 2
DOWEL . . . . . . . . . . . . . . . . . . . . . 2
PISTON . . . . . . . . . . . . . . . . . . . . . 2
(includes items 4-9)
908459/AP0603
Axles
552/553 Dynalift
Brake Group
(552: Thru S/N 1074; 553: Thru S/N 4831)
1
2
13
4
4
4
3
5
4
5
4
14
3
14
11
5
10
5
12
6
7
9
8
12
908459/AP0603
84
PRINTED IN U.S.A.
552/553 Dynalift
Axles
Brake Group
(552: Thru S/N 1074; 553: Thru S/N 4831)
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
.
07
08
09
10
11
12
13
14
L98435
L98436
L98437
L98438
L98439
L98440
L98441
L98442
01
02
03
04
05
06
L98429
L98430
L98431
L98432
L98433
L98434
PRINTED IN U.S.A.
PLUG. . . . . . . . . . . . . .
VENT BOLT . . . . . . . . .
SPACER . . . . . . . . . . .
BRAKE DISC . . . . . . . .
INTERMEDIATE DISC .
RING . . . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
2
8
8
8
85
Description
Qty.
Req.
RING . . . . . . . . . . . . . . . . . . . . . . . 8
PISTON . . . . . . . . . . . . . . . . . . . . . 8
SPACER . . . . . . . . . . . . . . . . . . . . 8
SPRING. . . . . . . . . . . . . . . . . . . . . 8
CUP SPRING. . . . . . . . . . . . . . . . 16
CIRCLIP. . . . . . . . . . . . . . . . . . . . 16
PIN . . . . . . . . . . . . . . . . . . . . . . . . 6
SPACER . . . . . . . . . . . . . . . . . . . . 2
908459/AP0603
Boom
552/553 Dynalift
552 - Outer Boom Section
18
27
10
19
17
16
15
14
11
1
20
21
12
13
2
24
1
9
20
21
22
23
5
4
3
20
8
21
6
7
26
908459/AP0603
86
25
PRINTED IN U.S.A.
552/553 Dynalift
Boom
01
02
03
04
05
06
07
08
09
10
11
12
L68346
L63024
L63099
L50462
L520019
L63056
L10465
L63131
L50226
L63272
L50273
L520005
L63274
L50273
L10057
L63017
L63273
L50273
L520005
L63314
L50209
L520003
L61708
L62715
L50251
L50147
PRINTED IN U.S.A.
OUTER SECTION WELD. . . . .
S/N 1015 & Up
Thru S/N 1014
BOOM PIVOT PIN . . . . . . . . . .
1/2”-13X5” BOLT . . . . . . . . . .
NYLON INSERT UT 1/2-13 . . .
BOOM PIVOT BUSHING . . . . .
GREASE ZERK 114-28 STR . .
REAR COVER . . . . . . . . . . . . .
SELF TAP SCREW 5/16-18X1
ROD END SLAVE CYL. PIN . .
3/8”-16X2-3/4” BOLT . . . . . . .
3/8”-16 NYLON INSERT NUT .
ROD END LIFT CYL. PIN. . . . .
3/8”-16X2-3/4”. . . . . . . . . . . . .
GREASE ZERK, 1/4-28X90. . .
LIFT CYL.. PIVOT BUSHING .
BUTT END EXT. CYL. PIN . . . .
3/8”-16X2-3/4” BOLT . . . . . . .
3/8”-16 NYLON INSERT NUT .
HOSE TRACK . . . . . . . . . . . . .
CAPSCREW 1/4-20X1/2 . . . .
NYLON INSERT NUT 1/4-20. .
SLIDE PAD 4X6 . . . . . . . . . . . .
BOLT LOCK TAB . . . . . . . . . . .
3/8”-16X3/4” BOLT . . . . . . . . .
3/8” LOCKWASHER . . . . . . . .
...1
13
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
14
15
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
2
2
2
1
1
1
1
2
2
1
2
1
1
1
1
4
4
2
2
6
6
16
17
18
19
20
21
22
23
24
25
26
27
87
L63694
L50368
L50147
L62733
L61709
L50403
L50147
L61709
L50251
L50147
L61704
L64143
L62715
L50261
L63717
L63715
L50561
L50143
L63720
L63719
L50884
L50143
L63012
L63199
L63014
L97956
L65638
L65640
EXT. CYL.. BRACKET . . . . . . . .
3/8”-16X1-1/4” BOLT GRD8 . . .
3/8” LOCKWASHER . . . . . . . . .
SHIM, 1/16. . . . . . . . . . . . . . . . .
SLIDE PAD 3X4 . . . . . . . . . . . . .
3/8”-16X1-1/4” BOLT GRD5. . . .
3/8” LOCKWASHER . . . . . . . . .
SLIDE PAD 3X4 . . . . . . . . . . . . .
3/8”-16X3/4” BOLT . . . . . . . . . .
3/8” LOCKWASHER . . . . . . . . .
SHIM, 1/4. . . . . . . . . . . . . . . . . .
SHIM, 1/2. . . . . . . . . . . . . . . . . .
BOLT LOCKTAB. . . . . . . . . . . . .
3/8”-16X1-1/2” BOLT . . . . . . . . .
TUBE CUSHION . . . . . . . . . . . .
CUSHION PLATE. . . . . . . . . . . .
5/16”-18X1-3/4” BOLT . . . . . . .
5/16” LOCKWASHER . . . . . . . .
TUBE CUSHION . . . . . . . . . . . .
CUSHION PLATE. . . . . . . . . . . .
5/16”-18X2-1/4” BOLT . . . . . . .
5/16” LOCKWASHER . . . . . . . .
EXTEND CYLINDER . . . . . . . . .
LIFT CYLINDER. . . . . . . . . . . . .
SLAVE CYLINDER. . . . . . . . . . .
BOOM ANGLE INDICATOR KIT .
INCLINOMETER . . . . . . . . . . . .
MOUNT PLATE. . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
2
2
2
2
4
4
2
4
4
2
2
2
4
6
3
6
6
2
1
2
2
1
1
1
1
1
1
908459/AP0603
Boom
552/553 Dynalift
552 - Inner Boom Section
12
10
11
20
9
24
21
25
22
17
13
23
16
19
14
15
8
18
3
26
4
5
1
2
6
7
908459/AP0603
88
PRINTED IN U.S.A.
552/553 Dynalift
Boom
552 - Inner Section Group
01
L98700
02
03
04
05
06
07
08
09
10
11
12
13
14
L63957
L63797
L50646
L65097
L65098
L63274
L50273
L520005
L10465
L63272
L50273
L520005
L63017
L68801
L63032
L63314
L510008
L50141
L520004
L63923
L510007
L50147
L570022
L50251
L50061
L63272
L50273
L520005
L63273
PRINTED IN U.S.A.
DYNATTACH WELDMENT . . . . . . 1
LOCK PLATE w/PIN. . . . . . . . . . . . 1
S/N 1011 & up
Thru S/N 1010
ROLL PIN 3/16X1-3/4. . . . . . . . . . . 1
SPRING. . . . . . . . . . . . . . . . . . . . . 1
SPRING MOUNT . . . . . . . . . . . . . . 1
DYNATTACH TO BOOM PIN . . . . . 2
3/8”-16X2-3/4” BOLT . . . . . . . . . . 2
GREASE ZERK 1/4-28 STR. . . . . 2
ROD END TILT CYL.PIN . . . . . . . . 1
3/8”-16x2-3/4” BOLT . . . . . . . . . . . 1
DYNATTCH PIVOT BUSHING . . . . 2
INNER SECTION WELD. . . . . . . . . 1
S/N 1057 & up
Thru S/N 1056
HOSE TRACK . . . . . . . . . . . . . . . . 1
5/16”-18X5/8” BOLT . . . . . . . . . . . 2
5/16” FLAT WASHER . . . . . . . . . . 2
HOSE TRAY WELD . . . . . . . . . . . . 1
3/8”-16X7/8” BOLT . . . . . . . . . . . . 2
3/8” LOCKWASHER . . . . . . . . . . . 2
CLAMP, 1/2 DIA . . . . . . . . . . . . . . . 2
3/8”-16X3/4” BOLT . . . . . . . . . . . . 2
3/8”-16 FLANGE NUT . . . . . . . . . . 2
ROD END EXT. CYL. PIN . . . . . . . 1
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 1
BUTT END TILT CYL.PIN. . . . . . . . 1
15
16
17
18
19
L50273
L520005
L61709
L62734
L62715
L50367
L61709
L62715
L50251
20
L61709
20
L61708
21
L61704
21
L62731
22
L64143
22
23
L62732
L62715
Thru S/N
L50403
24
25
26
89
L50261
L63717
L63715
L50561
L50143
L63013
3/8”-16X2-3/4” BOLT . . . . . . . . . . 2
SLIDE PAD 3X4 . . . . . . . . . . . . . . . 2
SHIM, 1/8X3 . . . . . . . . . . . . . . . . . 2
BOLT FLAT LOCK TAB . . . . . . . . . 2
3/8”-16X1” BOLT . . . . . . . . . . . . . . 4
SLIDE PAD 3X4” . . . . . . . . . . . . . . 2
BOLT LOCK TAB . . . . . . . . . . . . . . 2
3/8”-16X3/4” BOLT . . . . . . . . . . . . 4
PAD 3X4 . . . . . . . . . . . . . . . . . . . . 2
Thru S/N 1011
SLIDE PAD 4X6 . . . . . . . . . . . . . . . 2
S/N 1012 & Up
SPACER 1/4 . . . . . . . . . . . . . . . . . 2
Thru S/N 1011
SHIM 1/16X4 . . . . . . . . . . . . . . . . . 2
S/N 1012 & Up
SPACER 1/2 . . . . . . . . . . . . . . . . . 2
Thru S/N 1011
SHIM 1/8X4 . . . . . . . . . . . . . . . . . . 2
S/N 1012 & Up
BOLT LOCK TAB
1011, Qty of 2. S/N 1012 & Up, Qty of 4.
3/8”-16x1-1/4” BOLT. . . . . . . . . . . 8
S/N 1012 & Up
3/8”-16X1-1/2” BOLT . . . . . . . . . . . 4
Thru S/N 1011
HOSE CUSHION . . . . . . . . . . . . . . 2
CUSHION PLATE. . . . . . . . . . . . . . 1
5/16”-18X1-3/4” BOLT . . . . . . . . . 2
5/16” LOCKWASHER . . . . . . . . . . 2
TILT CYLINDER . . . . . . . . . . . . . . . 1
908459/AP0603
Boom
552/553 Dynalift
35
34
10
1
FRONT
32
33
27
30
2
3
31
4
5
6
27
7
29
28
23
8
24
9
27
25
10
22
26
25
12
11
21
13
14
15
15
20
16
908459/AP0603
90
19
18
17
16
REAR
PRINTED IN U.S.A.
552/553 Dynalift
Boom
Ref.
No.
Part
No.
01
02
03
04
05
06a
07
08
09
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
L68350
L63200
L70242
L65640
L50141
L52028
L65638
L50491
L50380
L50152
L50612
L63169
L63173
L63131
L50226
L68006
L63017
L520004
L50878
L68358
L68348
L63099
L50462
L520019
L63694
L50367
L50147
L61708
L62715
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
OUTER SECT. WELDMENT. . . . . . 1
S/N 3340 and Up
Thru S/N 3339
5/16”-18 NUTSERT . . . . . . . . . . . . 2
PLATE, BOOM ANGLE IND.. . . . . . 1
5/16” FLAT WASHER . . . . . . . . . . . 2
5/16”-18X1” BTNHD BOLT . . . . . . . 2
INCLINOMETER-ANGLE IND. . . . . 1
#8X5/8” RND HD MACH.SCREW. . 2
1/2”-20X1-1/4” BOLT . . . . . . . . . . . 2
1/2” LOCK WASHER . . . . . . . . . . . 2
PIN, COTTER 1/16”X3/4” . . . . . . . . 6
PIN, OUTER BOOM CLEVIS . . . . . 1
CLEVIS, OUTER BOOM . . . . . . . . 1
REAR OUTER COVER . . . . . . . . . 1
5/16”-18X1” SELF TAP SCREW . . . 4
BUSHING 2.5IDX2.75ODX4” . . . . . 2
LIFT CYL. PIVOT BUSHING . . . . . 2
5/16”-18X3” STUD . . . . . . . . . . . . . 4
CUSHION TOP PLATE. . . . . . . . . . 2
.88 HOSE CUSHION SINGLE . . . . 4
PIN, PIVOT PIN . . . . . . . . . . . . . . . 1
1/2”-13X5” BOLT . . . . . . . . . . . . . 1
1/2” NYLON INSERT NUT. . . . . . . 1
EXT. CYL. BRACKET. . . . . . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . 2
3/8” LOCK WASHER . . . . . . . . . . . 2
SLIDE PAD 5/8”X4”X6”. . . . . . . . . . 2
FLAT-BOLT LOCK . . . . . . . . . . . . . 2
25
26
27
28
29
30
31
32
33
34a
35
L50251
L50367
L50147
L61709
L62733
L50403
L64143
L50261
L63167
L63166
L50086
Description
Qty.
Req.
3/8”-16X3/4” BOLT . . . . . . . . . . . . . 6
3/8”-16X1” BOLT . . . . . . . . . . . . . . 2
3/8” LOCK WASHER . . . . . . . . . . 12
SLIDE PAD 5/8”X3”X4”. . . . . . . . . . 4
SHIM .06”X3”X4” . . . . . . . . . . . . . . 2
3/8”-16X1-1/4” BOLT . . . . . . . . . . . 4
SHIM 1/2”X3”X4” . . . . . . . . . . . . . . 2
3/8”-16X1-1/2” BOLT . . . . . . . . . . . 4
PIN, CLEVIS ADJUSTMENT . . . . . 2
CLEVIS, CHAIN ADJUSTMENT . . . 2
3/4”-10 NUT . . . . . . . . . . . . . . . . . . 4
--- ITEMS NOT SHOWN ---
a
91
L99007
L99008
HOSE TRACK KIT (Tilt) . . . . . . . . . 1
HOSE TRACK KIT (Tilt/Aux.) . . . . . 1
Thru S/N 3203
L99135
ABRASIVE SLEVE 1-3/4 DIA . . . . . .
S/N 3204 and Up
(Tilt, 16 ft.; Tilt/Aux, 32 ft.)
L50207
L50228
L520004
VINYL CLAMP . . . . . . . . . . . . . . . . 2
5/16”-18X1/2” BOLT . . . . . . . . . . . 2
Refer to Inner Boom Section for boom chains.
908459/AP0603
Boom
552/553 Dynalift
553 - Intermediate Boom Section
12
8
11
10
13
9
1
8
14
2
3
7
15
FRONT
4
5
6
16
17
18
19
21
20
17
16
19
12
8
11
10
22
9
8
27
13
23
2
24
28
25
29
26
16
21
19
17
19 17
21
16
19
16
21
REAR
1
908459/AP0603
92
PRINTED IN U.S.A.
552/553 Dynalift
Boom
553 - Intermediate Boom Section
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08cd
09
10
11
12
13
14c
15
16
17
18
19
20
L68744
L68650
L63006
L50228
L50207
L520004
L520005
L52026
L68697
L63158
L63157
L63153
L50273
L520005
L68695
L50367
L62715
L62734
L62733
L50251
L50147
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
INTERMEDIATE SECTION . . . . . . 1
Note a
Note b
TRAY, INTERMEDIATE . . . . . . . . . 1
5/16”-18X1/2” BOLT . . . . . . . . . . . . 1
CLAMP, VINLYL .69 DBL . . . . . . . . 1
5/16”X18 NYLON INSERT NUT . . . 1
3/8”-16X1-1/4” BOLT . . . . . . . . . . . 2
WASHER, CHAIN SHEAVE . . . . . . 6
RING, BEARING-INNER. . . . . . . . . 3
BEARING, BOOM SHEAVE . . . . . . 3
SHEAVE, CHAIN . . . . . . . . . . . . . . 3
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 2
PIN, FRONT SHEAVE . . . . . . . . . . 1
3/8”-16X1” BOLT . . . . . . . . . . . . . . 4
FLAT-BOLT LOCK . . . . . . . . . . . . 12
SHIM, .105”X3”X4” . . . . . . . . . . . . . 8
SHIM, .06”X3”X4”. . . . . . . . . . . . . . 2
3/8”-16X3/4” BOLT . . . . . . . . . . . . 28
3/8” LOCK WASHER . . . . . . . . . . . 8
21
22
23
24d
25
26
27
28
29
L61709
L50261
L50147
L68696
L63239
L61699
L61708
L62731
L62732
a
b
S/N 4519 & Up
Thru S/N 4518
c
Thru S/N 4518; order Front Sheave mount kit
P/N L500288 (includes sheave mounts and
items 8 and14)
d
Thru S/N 4518; order Rear Sheave mount kit
P/N L500289 (includes sheave mounts and
items 8 and 24)
SLIDE PAD, 5/8”X3”X4” . . . . . . . . 12
3/8”-16X1-1/2” BOLT . . . . . . . . . . . 1
3/8” LOCK WASHER . . . . . . . . . . . 1
PIN, REAR SHEAVE . . . . . . . . . . . 1
SPACER, TRAY BRACKET . . . . . . 1
SLIDE PAD, 2”X3” . . . . . . . . . . . . . 1
SLIDE PAD, 5/8”X4”X6” . . . . . . . . . 2
SHIM, .06”X4”X6”. . . . . . . . . . . . . . 2
SHIM, .105”X4”X6” . . . . . . . . . . . . . 2
Note: Refer to Inner Boom Section for boom chains.
93
908459/AP0603
Boom
552/553 Dynalift
REAR
14
16
13
6
7
8
5
1
9 10
17
15
12
11
18
2
19
7
4
3
27
21
26
20
10
3
7
9
11
25
9
24 23
22
22
FRONT
908459/AP0603
94
PRINTED IN U.S.A.
552/553 Dynalift
Boom
Ref.
No.
Part
No.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15a
16
L68762
L68649
L99980
L63005
L520004
L61699
L50207
L50228
L50251
L50147
L61709
L62734
L62715
L66783
L66782
L66780
L63156
L50612
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
INNER BOOM WELDMENT . . . . . . 1
S/N 4519 and Up
S/N 3952Thru 4518
Thru S/N 3951
HOSE TRAY, INNER BOOM. . . . . . 1
SLIDE PAD 2”X3”. . . . . . . . . . . . . . 1
CLAMP, VINYL .69 DBL . . . . . . . . . 1
5/16”-18X1/2” BOLT . . . . . . . . . . . . 1
3/8”-16X3/4” BOLT . . . . . . . . . . . . 17
3/8” LOCK WASHER . . . . . . . . . . . 1
SLIDE PAD 5/8”X3”X4”. . . . . . . . . . 4
SHIM .105”X3”X4” . . . . . . . . . . . . . 2
FLAT-BOLT LOCK . . . . . . . . . . . . . 8
SHIM .105”X3”X8” . . . . . . . . . . . . . 2
SHIM .06”X3”X8” . . . . . . . . . . . . . . 2
SLIDE PAD 3”x8” . . . . . . . . . . . . . . 2
CHAIN, BOOM LEAF . . . . . . . . . . . 2
PIN, COTTER 1/16”X3/4” . . . . . . . . 4
17
18b
19
20
21
22
23
24
25
26
27
L63168
L63156
L63166
L63167
L50086
L63017
L50877
L63716
L63715
L520005
L52026
a
Attaches from the rear of the inner boom to the
chain adjustment clevis’ located on the front of the
outer boom section. (Refer to Outer Boom Section,
item #34, chain adjustment clevis.)
b
Attaches from item #19 (chain adjustment clevis) to
outer boom clevis. (Refer to Outer Boom Section,
item #12, outer boom clevis.)
95
Description
Qty.
Req.
PIN, INNER BOOM CLEVIS. . . .
CHAIN, BOOM LEAF . . . . . . . . .
CLEVIS, CHAIN ADJUSTMENT .
PIN, CLEVIS ADJUSTMENT . . .
3/4”-10 NUT . . . . . . . . . . . . . . . .
BUSHING . . . . . . . . . . . . . . . . .
5/16”-18X2-1/4” STUD . . . . . . . .
CUSHION, HOSE-TWIN .68. . . .
PLATE, TWIN CUSHION TOP . .
3/8”-16 NYLON INSERT NUT. . .
3/8”-1-1/4” BOLT . . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
2
2
2
2
1
2
2
908459/AP0603
Boom
552/553 Dynalift
Dynattach
FRONT
3
1
4
2
5
14
13
Tilt Cylinder
3
6
7
8
9
12
2
11
10
9
908459/AP0603
96
PRINTED IN U.S.A.
552/553 Dynalift
Boom
Dynattach
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L98700
L520005
L50273
L63274
L63017
L63272
L68003
L63013
L66456
Description
Qty.
Req.
DYNATTACH WELDMENT . . . . . . . 1
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 3
PIN, TAPPED 1-1/2” DIA . . . . . . . . 2
BUSHING . . . . . . . . . . . . . . . . . . . 2
PIN, TILT CYL.(ROD END). . . . . . . 1
BUSHING, TILT CYL (ROD END) . . 1
TILT CYLINDER . . . . . . . . . . . . . . . 1
BUSHING, LOCK PIN. . . . . . . . . . . 2
Ref.
No.
Part
No.
10
11
12
13
14
L63326
Note a
L50646
L65097
L65098
a
L63957
L63797
PRINTED IN U.S.A.
97
Description
Qty.
Req.
PIN, DYNATTACH LOCK . . . . .
DYNATTACH LOCK WLDMNT .
3/16”X1-3/4” ROLL PIN . . . . . .
LOCK SPRING . . . . . . . . . . . .
SPRING MOUNT . . . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
LOCK PLATE WITH PIN
552: S/N 1011 & up
553: S/N 3062 & up
552: Thru S/N 1010
553: Thru S/N 3061
908459/AP0603
Hydraulics
552/553 Dynalift
Hydraulic Pump, Tank and Flow Divider
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
1
2
5
3
FRONT
6
7
4
8
9
Hydraulic
Pump
10
11
12
Transmission
19
18
17
13
16
14
9
Hydraulic
Tank
24 23
10
21
19
20
10
Flow
Divider
15
FRONT
23
24
22
02
FRONT
908459AP0603
98
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Hydraulic Pump, Tank and Flow Divider
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
Part
No.
01
02
03
04a
05
06
07
08
09
10
11
12
13
14
15
L445014
L63309
L46865
L68714
L50184
L50283
L62842
L69920
L68802
L445012
L63384
L68804
L445003
L63406
L50741
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
ADAP, -20ORM -24JICM 90DEG . . 1
HOSE, -24 A24/A24 35” . . . . . . . . . 1
GASKET, HYD PUMP . . . . . . . . . . 1
HYDRAULIC PUMP . . . . . . . . . . . . 1
1/2” FLAT WASHER . . . . . . . . . . . . 2
1/2”-13X1-1/4” BOLT . . . . . . . . . . . 2
ADAP, -4ORM -6JICM 90 DEG. . . . 1
HOSE, -4 A6/A6 40” . . . . . . . . . . . . 1
HOSE, -12 A12/A12 17” . . . . . . . . . 1
ADAP, -12ORM -12JICM 45 DEG. . 3
HOSE, -6 A8/DS8 40”. . . . . . . . . . . 1
HOSE, -4 A6/DS6 26”. . . . . . . . . . . 1
HOSE, -12 A12/DS12 114” . . . . . . . 1
STUD. . . . . . . . . . . . . . . . . . . . . . . 2
16a
17
18
19
20
21
22
23
24
25b
L68783
L444012
L445002
L68803
L68805
L68813
L441010
L444002
L446048
L68763
a
Refer to hydraulic breakdown section for a break
down of this component.
b
Refer to Hydraulic and Fuel Tanks located in
Chasis Section for complete list of parts.
FLOW DIVIDER . . . . . . . . . . . . .
ADAP, -4ORM -6JICM STR . . . .
ADAP, -8ORM -8JICM 90 DEG. .
HOSE, -4 A6/A6 40” . . . . . . . . . .
HOSE, -6 A6/DS6 70”. . . . . . . . .
HOSE, -4 A6/AS6 44”. . . . . . . . .
ADAP, -24NPTM -24JICM STR. .
ADAP, -6ORM PLUG . . . . . . . . .
HYDRAULIC TANK WELDMENT
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
1
3
1
1
HOSE LOCATOR
02
08
09
11
12
14
19
20
21
HYDRAULIC PUMP
HYDRAULIC PUMP
HYDRAULIC PUMP
HYDRAULIC PUMP
FLOW DIVIDER PORT “PF”
FLOW DIVIDER PORT “EF”
FLOW DIVIDER PORT “T”
HYDRAULIC TANK RETURN MANIFOLD
PRINTED IN U.S.A.
HYDRAULIC TANK
STEER MOTOR PORT “LS” (refer to next page)
FLOW DIVIDER PORT “IN”
STEER MOTOR PORT “P”
FRONT JOYSTICK- SIDE - (LOWER PORT)
V20 MAIN VALVE PORT (FRONT LEFT)
STEER MOTOR PORT “T” (UPPER LEFT)
FRONT JOYSTICK - SIDE - (UPPER PORT)
99
908459/AP0603
Hydraulics
552/553 Dynalift
Hydraulic Pump, Tank and Priority Valve
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
FRONT
3
10
Hydraulic
Tank
(Lower)
4
5
2
9
2
8
6
7
11
12
From
Main
Valve
To Top of
Hydraulic Tank
13
14
22
13
15
18
16
21
20
23
24
25
18
CF
17
EF
19
26
LS
P
27
T
18
A
29
FRONT
B
BYD
18
OUT
18
IN
28
13
908459AP0603
100
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Hydraulic Pump, Tank and Priority Valve
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
01
02
03
04
05
06
07
08
09
10a
11
12
13
14
15
16
Part
No.
L445014
L63309
L63308
L46865
L50184
L50283
L61092
L446019
L51493
L63402
L64311
L441010
L63216
L63396
L63395
L444001
L63502
L444002
L63390
Description
Qty.
Req.
ADAP, -20ORM -24JICM 90DEG
HOSE, -24 A24/A24 35” . . . . . . .
HYDRAULIC PUMP . . . . . . . . . .
GASKET, HYD PUMP . . . . . . . .
1/2” FLAT WASHER . . . . . . . . .
1/2”-13X1-1/4” BOLT . . . . . . . . .
ADAP, -16ORM -12JICM 90 . . . .
ADAP, -12JICFS 12JICM TEE . .
ADAP, -12JICF -6JICM. . . . . . . .
HOSE, -4 A4/A6 48” . . . . . . . . .
HOSE, -12 A12/A12 21” . . . . . . .
ADAP, -24NPTM -24JICM STR. .
HYDRAULIC TANK . . . . . . . . . .
HOSE, -12 DS12/A12 94”. . . . . .
HOSE, -12 DS12/A12 26”. . . . . .
ADAP, -12ORM -12JICM STR . .
MANIFOLD, HYDRAULIC . . . . .
ADAP, -6ORM -6JICM . . . . . . . .
HOSE, -6 DS8/A6 48” . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
2
1
2
1
Ref.
No.
Part
No.
Description
Qty.
Req.
17
18
19
20
21
22
23
24
25
26
27
28
29
L63380
L445001
L63408
L64179
L445002
L63384
L63385
L63385
L64311
L63379
L63143
L68313
L63406
a
Refer to Hydraulic and Fuel Tanks located in
Chasis Section for complete list of parts.
HOSE, -4 B4/A6 12”. . . . . . . . . . .
ADAP, -12ORM -12JICM 90 DEG.
HOSE, -12 DM12/A12 20” . . . . . .
PRIORITY VALVE . . . . . . . . . . . .
ADAP, -8ORM -8JICM 90 DEG. . .
HOSE, -6 A8/DS8 40”. . . . . . . . . .
HOSE, -4 A6/A6 62” . . . . . . . . . . .
HOSE, -4 A6/A6 62” . . . . . . . . . . .
HOSE, -12 A12/A12 21” . . . . . . . .
HOSE, -4 B4/A4 45”. . . . . . . . . . .
ADAP, -8ORM -6JICM STR . . . . .
FRAME LEVEL VLV w/RELIEF. . .
HOSE, -12 DS12/A12 114” . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
1
5
1
1
1
1
1
1
1
1
2
1
1
Note: Refer to hydraulic breakdown section for a break
down of this component.
HOSE LOCATOR
02
07
08
11
12
16
17
19
22
23
24
25
26
29
HYDRAULIC PUMP “IN”
HYDRAULIC PUMP (“OUT” RUN TEE)
HYDRAULIC PUMP (“OUT” RUN TEE)
HYDRAULIC MANIFOLD (TOP LEFT)
HYDRAULIC MANIFOLD (TOP RIGHT)
HYDRAULIC MANIFOLD (FRONT LEFT)
HYDRAULIC MANIFOLD (FRONT RIGHT)
HYDRAULIC MANIFOLD (LEFT SIDE)
PRIORITY VALVE “CF” PORT
LEVEL VALVE “A” PORT
LEVEL VALVE “B” PORT
PRIORITY VALVE “EF” PORT
PIRORITY VALVE “LS” PORT
LEVEL VALVE “BYD” PORT
PRINTED IN U.S.A.
HYDRAULIC TANK (LOWER)
TESTPORT (DASH)
PRIORITY VALVE “P” PORT
MAIN VALVE “OUT” (RELIEF VALVE)
HYDRAULIC TANK (FILTER)
STEER MOTOR “T” PORT
PRIORITY VALVE “T” PORT
PRIORITY VALVE “OUT” PORT
STEER MOTOR “P” PORT
LEVEL CYLINDER “EXTEND” PORT
LEVEL CYLINDER “RETRACT” PORT
LEVEL VALVE “IN” PORT
STEER MOTOR “LS” PORT
MAIN VALVE “IN” PORT
101
908459/AP0603
Hydraulics
552/553 Dynalift
Steer Motor and Steer Select Valve
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
LEFT
1
T
LS
FRONT
17
2
L
R
3
P
16
Steer Motor
15
12
13
14
Steer Select Valve
4
6
5
12
P
A
11
T
6
B
10
8
9
7
RIGHT
908459AP0603
102
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
01
02
03
04
05
06
07
08
Part
No.
Description
L68713
L62482
L63379
L50535
L69747
L68711
L445003
L63386
L520003
STEERING CONTROL UNIT . .
HOSE -4 B4/A4 45” . . . . . . . . .
1/4”-20X3” BOLT . . . . . . . . . . .
VALVE, STEER SELECT . . . . .
HARNESS, WIRE ADAPTER. .
HOSE, -6 A8/A6 36” . . . . . . . . .
1/4”-20 NYLON INSERT NUT. .
Qty.
Req.
Ref.
No.
Part
No.
Description
.
.
.
.
.
.
.
.
.
09
10
11
12
13
14
15
16
17
L444002
L63403
L63388
L63383
L63387
L63384
L68805
L64524
L444004
ADAP, -6ORM -6JICM STR
HOSE, -6 A8/DS6 110” . . . .
HOSE, -6 A8/DS6 100”. . . .
HOSE, -6 A6/DS8 52”. . . . .
HOSE, -6 A8/DS8 67”. . . . .
HOSE, -6 A8/DS8 40”. . . . .
HOSE, -6 A6/DS6 70”. . . . .
VALVE, CHECK . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
2
1
2
2
1
2
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
1
1
1
1
1
1
1
3
HOSE LOCATOR
03
07
10
11
12
13
14
15
STEER
STEER
STEER
STEER
STEER
STEER
STEER
STEER
MOTOR PORT “LS”
MOTOR PORT “R”
MOTOR PORT “L”
MOTOR PORT “P”
MOTOR PORT “T”
PRINTED IN U.S.A.
HYDRAULIC PUMP (item #8 on page 101)
STEER CYLINDER, FRONT AXLE RIGHT SIDE
STEER CYLINDER, REAR AXLE RIGHT SIDE
STEER CYLINDER, REAR AXLE LEFT SIDE
STEER SELECT VALVE PORT “P”
HYDRAULIC PUMP (item #11 on page 101)
103
908459/AP0603
Hydraulics
552/553 Dynalift
(552: Thru S/N 1056; 553: Thru S/N 4518)
LEFT
1
T
LS
FRONT
17
2
L
R
3
P
16
Steer Motor
15
12
13
14
Steer Select Valve
4
5
6
12
P
A
11
T
6
B
10
8
9
7
RIGHT
908459AP0603
104
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
Part
No.
Description
01
02
03
04
05
06
07
08
09
10
STEERING CONTROL UNIT . .
See note a
See note b
HOSE -4 B4/A4 45” . . . . . . . . .
1/4”-20X3” BOLT . . . . . . . . . . .
VALVE, STEER SELECT . . . . .
HARNESS, WIRE ADAPTER. .
ADAP, -6ORM -6JICM STR . . .
HOSE, -6 A8/A6 36” . . . . . . . . .
ADAP, -6ORM -6JICM STR . . .
HOSE, -6 A8/DS6 110” . . . . . . .
L66753
L64523
L51591
L63379
L50535
L69747
L68711
L444002
L63386
L520003
L444002
L63403
Qty.
Req.
Ref.
No.
Part
No.
Description
...1
11
12
13
14
15
16
17
L63388
L63383
L63387
L63384
L63390
L64524
L444004
HOSE, -6 A8/DS6 100”. . . .
HOSE, -6 A6/DS8 52”. . . . .
HOSE, -6 A8/DS8 67”. . . . .
HOSE, -6 A8/DS8 40”. . . . .
HOSE, -6 A6/DS8 48”. . . . .
VALVE, CHECK . . . . . . . . .
a
552: S/N 1012 Thru S/N 1056
553: S/N 3178 Thru S/N 4518
b
552: Thru S/N 1011
553: Thru S/N 3177
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
1
2
2
1
2
2
1
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
3
HOSE LOCATOR
03
07
10
11
12
13
14
15
STEER
STEER
STEER
STEER
STEER
STEER
STEER
STEER
MOTOR PORT “LS”
MOTOR PORT “R”
MOTOR PORT “L”
MOTOR PORT “P”
MOTOR PORT “T”
PRINTED IN U.S.A.
PRIORITY VALVE “LS” PORT
STEER CYLINDER, REAR AXLE RIGHT SIDE
STEER CYLINDER, REAR AXLE LEFT SIDE
STEER SELECT VALVE PORT “P”
PRIORITY VALVE “CF” PORT
HYDRAULIC MANIFOLD
105
908459/AP0603
Hydraulics
552/553 Dynalift
Main Valve Group
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
2
1
Left Side
Bulkhead
1
3
Right Side
Bulkhead
17
18
21
22
15
16
4
20
19
5
6
28
14 7
6
13
9
7
8
12
EL
LIFT
M
BOO T
TIL
10
LEV
B
11
A
23
7
FRONT
1
Optional
Hydraulics
24
25
26
27
908459AP0603
106
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Main Valve Group
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
Part
No.
01a
02
03
04
05
06
07a
08
09
10
11
12
13
14
L443011
L68814
L68814
L68816
L68815
L446026
L444008
L68817
L63407
L50895
L520004
L68694
L444001
L60253
Description
ADAP, BLKHEAD 90 -10JICM .
HOSE, -8 A10/DS10 15”. . . . . .
HOSE, -8 A10/DS10 15”. . . . . .
HOSE, -8 A10/DS8 14”. . . . . . .
HOSE, -8 A10/DS8 17”. . . . . . .
ADAP, -8JICFS -8JICM RUN T .
ADAP, -10ORM -8JICM . . . . . .
HOSE, -6 A8/A8 26” . . . . . . . . .
HOSE, -6 A8/A8 48” . . . . . . . . .
5/16”-18X3” BOLT . . . . . . . . . .
VALVE, MAIN CONTROL (V20)
ADAP, -12ORM -12JICM STR .
ADAP, -10ORM -JICM STR . . .
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
15
16
17
18
19
20
21
22
23
24
25
L63407
L63407
L68807
L68808
L68809
L68809
L63406
L68806
L68815
L68816
L68778
26
27
28
L445003
NSS
L444010
a
Add (2) to quanitity when unit is equipped with
optional hydraulics
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
4
1
1
1
1
4
4
1
1
3
3
1
2
2
Description
Qty.
Req.
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
HOSE, -6 A8/DS8 54”. . . . . . . . . . . 1
HOSE, -6 A8/DS8 48”. . . . . . . . . . . 1
HOSE, -4 A6/DS6 136”. . . . . . . . . . 1
HOSE, -4 A6/DS6 136”. . . . . . . . . . 1
HOSE, -12 A12/DS12 114” . . . . . . . 1
HOSE, -12 A12/DS12 120” . . . . . . . 1
HOSE, -8 A10/DS8 17”. . . . . . . . . . 1
HOSE, -8 A10/DS8 14”. . . . . . . . . . 1
KIT, VALVE SECTION . . . . . . . . . . 1
(includes item #27)
ADAP, -6ORM -6JICM 90 DEG. . . 10
BOLT KIT (included with item #25) . 1
ADAP, -10ORM -10JICM . . . . . . . . 2
HOSE LOCATOR
02
03
04
05
08
09
15
16
17
18
19
20
21
22
23
24
MAIN VALVE SECTION 3 PORT “A”
MAIN VALVE SECTION 3 PORT “B”
MAIN VALVE “IN”
MAIN VALVE “OUT”
OPTIONAL HYD. SECTION PORT “B”
OPTIONAL HYD. SECTION PORT “A”
PRINTED IN U.S.A.
BULKHEAD FITTING TO (BOOM EXTEND)
BULKHEAD FITTING TO (BOOM RETRACT)
BULKHEAD FITTING TO (TILT CYL. RETRACT)
BULKHEAD FITTING TO (TILT CYL. EXTEND)
SLAVE CYLINDER (BOTTOM-RETRACT)
SLAVE CYLINDER (TOP-EXTEND)
LIFT CYLINDER (RIGHT) (OUTSIDE-EXTEND)
LIFT CYLINDER (RIGHT) (INSIDE-RETRACT)
LIFT CYLINDER (LEFT) (OUTSIDE-RETRACT)
LIFT CYLINDER (LEFT) (INSIDE-EXTEND)
LEVEL CYLINDER (OUTSIDE-RETRACT)
LEVEL CYLINDER (INSIDE-EXTEND)
FLOW DIVIDER PORT “EF”
HYDRAULIC TANK (FILTER COVER FITTING)
BULKHEAD FITTING TO (OPTION - RETRACT)
BULKHEAD FITTING TO (OPTION - EXTEND)
107
908459/AP0603
Hydraulics
552/553 Dynalift
Main Valve Group
(552: Thru S/N 1056; 553: Thru S/N 4518)
D
EA
1
KH
T
IGH
L
BU
R
2
22
1
3
AD
HE
FT
6
K
UL
B
LE
5
4
Auxilary Hydraulics
(Optional)
8
10
11
7
12
9
21
29
B
18
A
13
19
19
1
TIL
T
BO
BO
OM
OM
17
20
LIF
15
T
EX
14
TE
ND
16
28
12
22
21
26
27
1
23
24
FRONT
908459AP0603
Auxilary Hydraulics
(Optional)
108
19
25
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Main Valve Group
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
Part
No.
01a
02
L443011
L68373
L63389
03
04
05
06
07
08
09
10
L68372
L63389
L63397
L63398
L63407
L63407
L446026
L444003
L68370
L63392
11
12
13
14
15
L68371
L63392
L445002
L64658
L444004
L68369
L63394
16
17
18
L68353
L63393
L63490
L68357
L63401
Description
Qty.
Req.
ADAP, BLKHEAD 90 -10JICM . . . AR
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 A10/DS8 20”)
See note b (-8 A8/H8 58”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note b (-8 A8/H8 58”)
HOSE, -6 DS8/A8 60” . . . . . . . . . . 1
HOSE, -6 DS8/A8 64” . . . . . . . . . . 1
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
ADAP, -8JICFS -8JICM RUN T . . . . 4
ADAP, -12ORM -8JICM STR . . . . . 4
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 DS8/A8 18”)
See note b (-6 DS8/A8 20”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note b (-6 DS8/A8 20”)
ADAP, -8ORM -8JICM 90 DEG . . AR
RELIEF VALVE . . . . . . . . . . . . . . . 1
ADAP, -8ORM -8JICM STR . . . . . . 2
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-6 DL8/A8 51”)
See note b (-6 A8/A8 27”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note b (-6 A8/A8 19”)
ADAP, -10ORM -12JICM BR TEE. . 1
HOSE/TUBE, VALVE TO RELIEF . . 1
See note a (Uses a tube)
See note b (Hose -12 A12/A12 35”)
Ref.
No.
Part
No.
19
20
21
22
L445001
L63396
L63406
23
24
25
26
L68239
L63599
L444001
L65557
L64411
L68364
L63391
27
P47135
L445006
28
29
L68363
L63391
L63125
Description
Qty.
Req.
ADAP, -12ORM -12JICM 90 DEG. .
HOSE, -12 DS12/A12 94”. . . . . . . .
HOSE, -12 DS12/A12 114” . . . . . . .
HOSE, AUXILARY HYD . . . . . . . . .
See note a (-8 H10/DS10 54”)
See note b (-6 H8/A8 72”)
ADAP, -12ORM -12JICFS SWVL . .
AUXILARY VALVE . . . . . . . . . . . . .
VALVE TO BLKHEAD (LEFT) . . . . .
See note b (Hose, -8 DM8/A8 92”)
ADAPTER, HYDRAULIC . . . . . . . .
See note a
(ADAP, -12ORM -10JICM STR)
See note b
(ADAP -12ORM -8JICM 90 DEG)
VALVE TO BLKHEAD (RIGHT). . . .
See note b (Hose, -8 DM8/A8 92”)
MAIN VALVE . . . . . . . . . . . . . . . . .
a
For units:
552: S/N 1015 Thru S/N 1056
553: S/N 3340 Thru S/N 4518
b
For units:
552: Thru S/N 1014
553: Thru S/N 3339
2
1
1
2
1
1
1
1
2
1
1
Note: Port “A” is the extend side of the valve
Port “B” is the retract side of the valve
HOSE LOCATOR
02
03
04
05
06
07
10
11
15
16
18
20
21
22
22
MAIN VALVE TILT SECTION PORT “A”
MAIN VALVE TILT SECTION PORT “B”
MAIN VALVE LIFT SECTION PORT “A”
MAIN VALVE LIFT SECTION PORT “B”
MAIN VALVE LIFT SECTION PORT “B”
MAIN VALVE LIFT SECTION PORT “A”
MAIN VALVE TILT SECTION PORT “A”
MAIN VALVE TILT SECTION PORT “B”
RELIEF VALVE LOWER PORT “P1”
RELIEF VALVE LOWER PORT “P2”
MAIN VALVE “OUT”
RELIEF VALVE PORT “T”
MAIN VALVE “IN”
AUXILARY HYD. SECTION PORT “A”
AUXILARY HYD. SECTION PORT “B”
BULKHEAD FITTING* TO (TILT CYL. EXTEND)
BULKHEAD FITTING* TO (TILT CYL. RETRACT)
LIFT CYLINDER (LEFT) (EXTEND)
LIFT CYLINDER (LEFT) (RETRACT)
LIFT CYLINDER (RIGHT) (RETRACT)
LIFT CYLINDER (RIGHT) (EXTEND)
RELIEF VALVE UPPER PORT “P2”
RELIEF VALVE UPPER PORT “P1”
SLAVE CYLINDER (RETRACT)
SLAVE CYLINDER (EXTEND)
RELIEF VALVE “T”
HYDRAULIC MANIFOLD
LEVEL VALVE “BYD”
BULKHEAD FITTING TO (OPTION - EXTEND)
BULKHEAD FITTING TO (OPTION - RETRACT)
* Bulkhead fittings not used on older units, hose connects directly to tube on boom which goes to tilt cylinder.
PRINTED IN U.S.A.
109
908459/AP0603
Hydraulics
552/553 Dynalift
Joystick Group
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
1
FRONT
3
Level
Tilt
4
2
Level
Optional
Hydraulics
Tilt
Lift
Boom
5
Boom
Lift
13
6
12
3
5
7
3
3
9
8
8
9
4
3
Optional
Hydraulics
8
9
Level
Lift
Boom
5
Tilt
Retract
5
10
5
Extend
11
REAR
908459AP0603
Optional
Hydraulics
110
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Joystick Group
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
01
02a
03b
04c
05b
06c
07
08b
09b
Part
No.
L68775
L50211
L50051
L62553
L50211
L50051
L444002
L68824
L445003
L60302
L50211
L50051
L68812
L68811
L68810
Description
Qty.
Req.
JOYSTICK, W/GATE . . . . . . . . . . . 1
1/4”-20X3/4” BOLT . . . . . . . . . . . . 4
1/4”-20 FLANGE NUT . . . . . . . . . . 4
JOYSTICK . . . . . . . . . . . . . . . . . . . 1
1/4”-20X3/4” BOLT . . . . . . . . . . . . 4
1/4”-20 FLANGE NUT . . . . . . . . . . 4
ADAP, -6ORM -6JICM . . . . . . . . . 12
HOSE, -4 A6/DS6 20”. . . . . . . . . . . 2
JOYSTICK, 2 WAY . . . . . . . . . . . . 1
1/4”-20X3/4” BOLT . . . . . . . . . . . . 4
1/4”-20 FLANGE NUT . . . . . . . . . . 4
HOSE, -4 A6/B6 18” . . . . . . . . . . . . 2
HOSE, -4 A6/A6 108” (retract) . . . . 4
HOSE, -4 A6/A6 96” (extend) . . . . . 4
Ref.
No.
10c
11
12
13
Part
No.
L68778
L68694
L68804
L68805
Description
a
Use (2) L446048 -6ORM Plugs when not equipped
with optional hydraulics.
b
Hydraulic option requires (4) additional L444002
fittings and (4) additional L445003 fittings and
(1) additional L68810 hose and (1) additional
L68811 hose.
c
Used only on units equipped with hydraulic option.
KIT, VALVE SECTION . . .
VALVE, MAIN CONTROL .
HOSE, -4 A6/DS6 26”. . . .
HOSE, -4 A6/DS6 70”. . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Qty.
Req.
...1
...1
...1
...1
HOSE LOCATOR
12
13
FRONT JOYSTICK - SIDE - (LOWER PORT)
FRONT JOYSTICK - SIDE - (UPPER PORT)
FLOW DIVIDER PORT “PF”
Other hoses are located as shown in illustration.
PRINTED IN U.S.A.
111
908459/AP0603
Hydraulics
552/553 Dynalift
Joystick Group
(552: Thru S/N 1056; 553: Thru S/N 4518)
Boom Control
Auxilary Hydraulic
REAR
Tilt/Level
3
1
2
6
Joystick Panel
(Inside Cab)
4
5
Boom Lift
Tilt
Main Valve
(Rear of Unit)
Boom Extend
Auxilary Hydraulics
7
Frame Level Valve
(Front of Unit)
FRONT
908459AP0603
112
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Joystick Group
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
01
02
03
Part
No.
L63345
L52024
L50051
L45666
L63345
L52024
L50051
L45666
L50056
L63127
L63457
L52025
L50056
PRINTED IN U.S.A.
Description
Qty.
Req.
TILT/LEVEL JOYSTICK . . . . . . . . .
1/4”-20X1” BUTT. HD BOLT . . . . .
1/4”-20 FLANGE NUT . . . . . . . . . .
VINYL CLAMP 1” . . . . . . . . . . . . .
BOOM CONTROL JOYSTICK . . . .
1/4”-20X1” BUTT. HD BOLT . . . . .
1/4”-20 FLANGE NUT . . . . . . . . . .
VINYL CLAMP 1” . . . . . . . . . . . . .
5/16”-18 FLANGE NUT . . . . . . . . .
AUXILARY FUNCTION JOYSTICK.
MOUNT . . . . . . . . . . . . . . . . . . . .
5/16”-18X3/4” BUTT. HD BOLT . . .
5/16”-18 FLANGE NUT . . . . . . . . .
1
4
4
2
1
4
4
2
1
1
1
2
2
Ref.
No.
Part
No.
Description
04
05
06
07
L63128
L63630
L63128
L63476
L50055
L65842
L50612
LIFT/EXT/AUX CABLE ASY..
TILT CABLE ASSEMBLY . . .
FRAME LEVEL CABLE ASY.
CABLE ADAPTER. . . . . . . .
1/4”-28 NUT . . . . . . . . . . . .
1/4”-1-1/8” CLEVIS PIN . . . .
1/16” COTTER PIN . . . . . . .
113
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
3
1
1
4
4
4
4
908459/AP0603
Hydraulics
552/553 Dynalift
Frame Level Group
3
LEFT
2
1
4
5
6
FRONT
7
7
8
9
REAR
16
10
11
15
12
RIGHT
FR
14
Main Control
Valve (V20)
Newer Models
ON
TA
XL
13
E
Frame Level
Valve
(Older Units)
19
17
18
Level Section
Located at front of unit
Located at rear of unit
908459AP0603
114
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Frame Level Group
Ref.
No.
01
02
03
04
05
06
Part
No.
L63015
L64367
L50277
L63276
L520005
L68794
L445005
07
L68809
L63385
08
09c
10
11
12
L50403
L50275
L520005
L68881
L68882
L63275
L63016
L68878
L63009
PRINTED IN U.S.A.
Description
Qty.
Req.
LEVEL CYLINDER . . . . . . . . . . . . . 1
BRONZE BEARING . . . . . . . . . . . . 1
3/8”-16X3-1/2” BOLT . . . . . . . . . . . 1
PIN, CYLINDER (Base End). . . . . . 1
ADAPTER, HYDRAULIC . . . . . . . . 2
See note a (W/ORF -8ORM-6JICM)
See note b (-8ORM -6JICM 90DEG)
HOSE
See note a (-4 A6/DS6 136”) . . . . . 2
See note b, (-4 A6/A6 62”) . . . . . . . 2
BOLT . . . . . . . . . . . . . . . . . . . . . . . 1
Note c (3/8”-16X1-1/4” BOLT)
Note d (3/8”-16x3” BOLT)
3/8”-16 LOCK NUT
LOCK, PIVOT PIN . . . . . . . . . . . . . 1
PIVOT PIN (Rod End) . . . . . . . . . . 1
See note c
See note d
BRONZE BEARING . . . . . . . . . . . . 1
FRAME LEVEL MOUNT. . . . . . . . . 1
See note c
See note d
Ref.
No.
Part
No.
13
14
15
16
17a
18b
19b
L68876
L63115
L50712
L50157
L50084
L60253
L63128
L63143
Description
PLATE, FRAME LEVEL . . . . . .
See note c
See note d
3/4”-10X9” GR8 BOLT . . . . . . .
3/4” FLAT WASHER . . . . . . . . .
3/4”-10 STOVER NUT . . . . . . .
ADAP, -10ORM -6JICM . . . . . .
FRAME LEVEL CABLE ASY. . .
ADAP, -8ORM -6JICM W/ORF..
a
552: S/N 1057 and Up
553: S/N 4519 and Up
b
552: Thru S/N 1056
553: Thru S/N 4518
c
552: S/N 1075 and Up
553: S/N 4832 and Up
d
552: Thru S/N 1074
553: Thru S/N 4831
115
Qty.
Req.
...1
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
4
4
4
2
1
2
908459/AP0603
Hydraulics
552/553 Dynalift
Lift Cylinder Group
2
1
3
4
RIGHT
5
LEFT
6
11
7
12
Main Valve
(Newer Style
Shown)
9
EXTEND
10
RETRACT
12
FRAME
EXTEND
8
RETRACT
LIFT
4
5
3
FRONT
FRAME
908459AP0603
2
116
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Lift Cylinder Group
Ref.
No.
01
02
03
04
05
06
07
Part
No.
L63199
L63017
L63274
L50273
L520005
L446026
L444008
L444003
08
L68807
L63398
PRINTED IN U.S.A.
Description
Qty.
Req.
LIFT CYLINDER. . . . . . . . . . . . . . . 2
BRONZE BUSHING . . . . . . . . . . . . 4
PIN, LIFT CYLINDER . . . . . . . . . . . 4
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 4
ADAP -8JICFS -8JICM RUN TEE . . 2
See note a (-10ORM -8JICM STR)
See note b (-12ORM -8JICM STR)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note b (-6 A8/DS8 64”)
Ref.
No.
Part
No.
09
10
11
12
L68808
L63397
L63407
L63407
L445002
Description
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note b (-6 A8/DS8 60”)
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
HOSE, -6 A8/A8 48” . . . . . . . . . . . . 1
ADAP -8ORM -8JICM 90 DEG . . . . 4
a
552: S/N 1057 and Up
553: S/N 4519 and Up
b
552: Thru S/N 1056
553: Thru S/N 4518
117
Qty.
Req.
908459/AP0603
Hydraulics
552/553 Dynalift
Tilt / Slave Cylinder Group
2
1
3
Extend
25
24
Retract
13
23
12
18
5
14
22
17
4
Right Bulkhead
15
6
Slave
Cylinder
12
16
11
7
11
21
Retract
8
10
Extend
20
13
Extend
Tilt
Cylinder
13
19
Main Valve
(Newer style shown)
12
TILT
18
17
12
26
14
9
Retract
Refer to page 110
(Main Valve Group)
for details on older units
15
13
FRONT
908459AP0603
118
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Tilt / Slave Cylinder Group
Ref.
No.
Part
No.
01
L68351
L63145
02
L68239
L63389
03
04ag
05cg
06cg
07g
08
09cg
10cg
11
12
13
14
15
16
17
18
19
20
L68239
L63389
L443011
L68815
L68816
L446026
L444008
L444003
L68817
L63407
L445002
L520005
L50273
L63272
L63018
L63014
L68003
L63273
L63013
L68374
L68375
L63409
L63405
21
L68374
L68375
L63409
L63405
PRINTED IN U.S.A.
Description
Qty.
Req.
TUBE, TILT/AUX . . . . . . . . . . . . . . 2
See note a
See note b
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 H10/DS10 54”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 H10/DS10 54”)
ADAP, -10JICM BLKHEAD 90DEG. 2
HOSE, -8 A10/DS8 17”. . . . . . . . . . 1
HOSE, -8 A10/DS8 14”. . . . . . . . . . 1
ADAP, -8JICFS -8JICM RUN TEE . 2
See note c -10ORM -8JICM
See note d -12ORM -8JICM
HOSE, -6 A8/A8 26” . . . . . . . . . . . 1
HOSE -6 A8/A8 48” . . . . . . . . . . . . 1
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 4
PIN, CYLINDER (ROD END) . . . . . 2
BUSHING (ROD END) . . . . . . . . . . 2
CYLINDER, SLAVE . . . . . . . . . . . . 1
BUSHING (BASE END) . . . . . . . . . 2
PIN, CYLINDER (BUTT END) . . . . 2
CYLINDER, TILT . . . . . . . . . . . . . . 1
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
Note a & f (-6X 322”) Used on 553
Note a (-6X205”) Used on 552
Note b & f (-6X318”) Used on 553
Note b (-6X203”) Used on 552
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
Note a & f (-6X 322”) Used on 553
Note a (-6X205”) Used on 552
Note b & f (-6X318”) Used on 553
Note b (-6X203”) Used on 552
Ref.
No.
Part
No.
22
23
24
25
26
L520004
L50877
L63715
L68039
L444004
L445002
Description
Qty.
Req.
5/16”-18X2-1/4” STUD . . . . . . . . . . 8
PLATE, TWIN CUSHION . . . . . . . . 8
5/8” DOUBLE TUBE CUSHION . . 16
See note a (-8ORM -8JICM STR)
See note b (-8ORM -8JICM 90 DEG)
--- ITEMS NOT SHOWN --L50207
VINYL CLAMP . . . . . . . . . . . . . . . . 2
L50228
5/16”-18X1/2” BOLT . . . . . . . . . . . 2
L520004
a
552: S/N 1015 and Up
553: S/N 3340 and Up
b
552: Thru S/N 1014
553: Thru S/N 3339
c
552: S/N 1057 and Up
553: S/N 4519 and Up
d
552: Thru S/N 1056
553: Thru S/N 4518
e
552: S/N 1015 Thru S/N 1056
553: S/N 3340 Thru S/N 4518
f
Protective Sleeve Part Number is L99135.
g
Refer to page 110 “Main Valve Group” for more
hoses, fittings and location of parts used on older
models.
119
908459/AP0603
Hydraulics
552/553 Dynalift
Boom Extend Cylinder Group
4
5
3
6
7
2
8
5
1
3
9
12
10
2
11
19
12
18
11
13
17
16
14
15
Retract
FRONT
Extend
Main Valve
(Newer style shown)
Boom
Extend
Refer to page 110
(Main Valve Group)
908459AP0603
120
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Boom Extend Cylinder Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
Part
No.
L63012
L443022
L445002
L520005
L63273
L50273
L68003
L68348
L68356
L50878
L520004
L68352
L63391
12
L68352
L63391
13
L68814
L68363
N/A
14
L68814
L68364
N/A
15
L444010
P47135
L445006
PRINTED IN U.S.A.
Description
Qty.
Req.
Ref.
No.
Part
No.
CYLINDER, EXTEND. . . . . . . . . . . 1
Note a (-8ORM -8JICM 90 LONG)
Note b (-8ORM -8JICM 90)
PIN, CYLINDER (BUTT END) . . . . 1
3/8”-16X2-3/4” BOLT . . . . . . . . . . . 2
BUSHING (BUTT END) . . . . . . . . . 1
7/8” HOSE CUSHION, SINGLE . . . 4
CUSHION TOP PLATE. . . . . . . . . . 2
5/-16”-18X3” STUD . . . . . . . . . . . . 4
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
Note a (-8 A8/DS10 73”)
Note b & g (-8 A8/DM8 92”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
Note a (-8 A8/DS10 73”)
Note b & g (-8 A8/DM8 92”)
HOSE/TUBE . . . . . . . . . . . . . . . . . 1
Note a (-8 A10/DS10 15”)
Note e (Tube)
Note b & f
HOSE/TUBE . . . . . . . . . . . . . . . . . 1
Note a (-8 A10/DS10 15”)
Note e (Tube)
Note b & f
Note c (-10ORM -10JICM)
Note e (-12ORM -10JICM STR)
Note b (-12ORM -8JICM 90 DEG)
16ag
17
L443011
L63694
L50367
L50147
L63018
L63272
18
19
Description
Qty.
Req.
ADAP, -10JICM 90 BLKHEAD
EXTEND CYL. BRACKET . . .
3/8”-16X1” BOLT . . . . . . . . . .
3/8” LOCK WASHER . . . . . . .
BUSHING (ROD END) . . . . . .
PIN, CYLINDER (ROD END) .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
a
552: S/N 1015 and Up
553: S/N 3340 and Up
b
552: Thru S/N 1014
553: Thru S/N 3339
c
552: S/N 1057 and Up
553: S/N 4519 and Up
d
552: Thru S/N 1056
553: Thru S/N 4518
e
552: S/N 1015 Thru S/N 1056
553: S/N 3340 Thru S/N 4518
f
hoses, fittings and location of parts used on older
models.
g
Item #16 is not used with units listed in note b.
121
.
.
.
.
.
.
2
1
2
2
1
1
908459/AP0603
Hydraulics
552/553 Dynalift
Auxilary Hydraulics Group
1
2
3
12
11
14
10
13
9
8
15
7
16
6
9
17
Auxilary Hydraulics
Valve Section
11
13
18
5
Left Bulkhead
14
21
19
Refer to page 110
(Main Valve Group)
4
20
FRONT
908459AP0603
122
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Auxilary Hydraulics Group
Ref.
No.
Part
No.
01
L68351
L63145
02
L68239
L63389
03
04ag
05cgh
06cg
07
L68239
L63389
L443011
L68778
L444008
L68815
L68239
L63599
08
09
10
11
12
13
L68816
L68239
L63599
L520004
L50877
L63715
L68039
L68376
L68377
L63601
L63600
14
L68376
L68377
L63601
L63600
PRINTED IN U.S.A.
Description
Qty.
Req.
TUBE, TILT/AUX . . . . . . . . . . . . . . 2
See note a
See note b
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 H10/DS10 54”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a (-8 H10/DS10 54”)
ADAP, -10JICM BLKHEAD 90DEG. 2
KIT, VALVE SECTION . . . . . . . . . . 1
ADAP, -10ORM -8JICM . . . . . . . . . 2
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note c (-8 A10/DS8 17”)
See note e (-8 H10/DS10 54”)
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note c (-8 A10/DS8 14”)
See note e (-8 H10/DS10 54”)
5/16”-18X2-1/4” STUD . . . . . . . . . . 8
PLATE, TWIN CUSHION . . . . . . . . 8
5/8” DOUBLE TUBE CUSHION . . 16
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a & f (-6x252”)Used on 553
See note a (-6x237”) Used on 552
See note b & f (-6x342”)Used on 553
See Note b (-6x227”) Used on 552
HOSE . . . . . . . . . . . . . . . . . . . . . . 1
See note a & f (-6x252”)Used on 553
See note a (-6x237”) Used on 552
See note b & f (-6x342”)Used on 553
See Note b (-6x227”) Used on 552
Ref.
No.
Part
No.
15
16
17
L50228
L50207
L50545
L50143
L63716
L444004
NSS
NSS
18
19
20i
21i
Description
Qty.
Req.
3/8”-16X1/2” BOLT . . . . . . . . . . . .
VINYL CLAMP . . . . . . . . . . . . . . .
5/16”-18X2-3/4” BOLT . . . . . . . . .
5/16” LOCK WASHER. . . . . . . . .
11/16” DOUBLE TUBE CUSHI0N .
ADAP, -8ORM -8JICM STR . . . . .
COUPLER, MALE . . . . . . . . . . . .
COUPLER, FEMALE . . . . . . . . . .
a
552: S/N 1015 and Up
553: S/N 3340 and Up
b
552: Thru S/N 1014
553: Thru S/N 3339
c
552: S/N 1057 and Up
553: S/N 4519 and Up
d
552: Thru S/N 1056
553: Thru S/N 4518
e
552: S/N 1015 Thru S/N 1056
553: S/N 3340 Thru S/N 4518
f
Protective Sleeve Part Number is L99135.
g
hoses, fittings, components and location of parts
used on older models.
h
Kit includes a single V20 valve section and tie
bolt kit for five section valve.
i
Sold as a set, order part #L65273
123
.
.
.
.
.
.
.
.
2
2
2
2
4
2
1
1
908459/AP0603
Hydraulics
552/553 Dynalift
Hydraulic Pump Breakdown
552: Thru S/N 1056
553: Thru S/N 4518
552: S/N 1057 and Up
553: S/N 4519 and Up
1
1
2
2
3
Ref.
No.
01
02
03
Part
No.
L68714
L46865
L500368
908459AP0603
Description
3
Qty.
Req.
HYDRAULIC PUMP . . . . . . . . . . . . 1
GASKET . . . . . . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
(Items included are not shown)
Ref.
No.
Part
No.
01
02
03
L63308
L46865
L99009
L97665
Description
HYDRAULIC PUMP . . . . . . . . . . . . 1
GASKET . . . . . . . . . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
See note a
See note b
a
552: S/N 1009 Thru S/N 1056
553: S/N 3099 Thru S/N 4518
b
552: Thru S/N 1008
553: Thru S/N 3099
124
Qty.
Req.
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Flow Divider Breakdown
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
3
2
1
4
Ref.
No.
Part
No.
01
L68783
02
L99928
L99929
PRINTED IN U.S.A.
Description
Qty.
Req.
FLOW DIVIDER . . . . . . . . . . . . . . . 1
(Includes all items shown)
PRESSURE REGULATOR . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . 1
5
Ref.
No.
Part
No.
03
L99927
L99925
P471997
L62840
04
05
125
Description
Qty.
Req.
RELIEF VALVE (350 PSI).
SEAL KIT . . . . . . . . . . . .
TEST PORT. . . . . . . . . . .
CAP, DUST COVER . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
2
908459/AP0603
Hydraulics
552/553 Dynalift
Main Valve Breakdown
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
1
12
10
9
FRONT
11
3
3
6
4
8
13
7
3
9
5
6
4
3
TILT
4
‘B’ PORT
BOOM
2
14
IN
14
4
OUT
1
LIFT
14
12
16
17
15
LEVEL
14
‘A’ PORT
3
4
19
4
18
Auxilary Hydraulics
Work Section
14
SEAL KITS
20
908459AP0603
126
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L68694
MAIN VALVE [V20] (Complete). . . . 1
01
02
03
04
05
L98891
L500954
L500134
L500132
L500130
L98895
06
07
L500952
L500953
08
L500956
09
L98896
L98897
L98898
L98899
STUD KIT (tie bolts and nuts) . . . . . 1
INLET COVER . . . . . . . . . . . . . . . . 1
HRO ACUATOR “B” END . . . . . . . . 4
NO RELIEF-NO ANTI-CAV.PLUG . . 4
SEAL KIT . . . . . . . . . . . . . . . . . . . 1
WORK SECTION 1 (Level). . . . . . . 1
(includes items 3, 4, 14 & 15)
NO RELIEF - ANTI-CAV PLUG. . . . 1
WORK SECTION 2 (Lift) . . . . . . . . 1
(includes items 3, 4, 6, 14 & 15)
WORK SECTION 3 (Boom Ext.). . . 1
(includes items 3, 4, 6, 14 & 15)
RELIEF CARTRIDGE. . . . . . . . . . . 2
SERVICE KIT (less seals) . . . . . . . 2
SEAL KIT . . . . . . . . . . . . . . . . . . . 2
WORK SECTION 4 (Tilt) . . . . . . . . 1
(includes items 3, 9, 14 & 15)
10
PRINTED IN U.S.A.
Ref.
No.
Part
No.
11
12
13
14
15
L500955
L500957
L500959
L500135
L500961
654022
L500129
L96580
L500958
16
17
18
L500127
L98887
19
20
127
L98895
L500960
Description
Qty.
Req.
OUTLET COVER . . . . . . . . . . . . . . 1
PLUG SAE-12
PLUG SAE 12 (SOCKET HEAD) . . 1
HRO ACUATOR “A” END . . . . . . . . 4
SCREW . . . . . . . . . . . . . . . . . . . 32
LOCK WASHER . . . . . . . . . . . . . 32
RELIEF CARTRIDGE (RP51-A) . . . 1
RELIEF SEAL KIT . . . . . . . . . . . . . 1
PLUG WITH TEST PLUG. . . . . . . . 1
SEAL KITS FOR WORK SECTIONS
SECTION SEAL KIT . . . . . . . . . . 1ea
(used with items 5-7 & 10)
SPOOL SEAL KIT . . . . . . . . . . . 1ea
(used with items 3 & 14)
WORK SECTION (Aux. Hyd.). . . . . 1
STUD ASSEMBLY KIT (Aux. Hyd.) . 1
(used with item 20)
908459/AP0603
Hydraulics
552/553 Dynalift
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
B
OUT
BYD
B
A
B
A
A
5
IN
2
4
6
Ref.
No.
Part
No.
01
L63125
02
03
L50612
L63476
L50055
L65842
04
908459AP0603
Description
MAIN VALVE (Complete)
(excludes items 2-4)
1/16” COTTER PIN . . . .
CABLE ADAPTER . . . . .
1/4”-28 NUT . . . . . . . . .
1/4”-1-1/8” CLEVIS PIN .
3
Qty.
Req.
Ref.
No.
Part
No.
........1
05a
L98500
06
L98502
a
Requires one kit per section.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
3
3
3
3
128
Description
Qty.
Req.
SPRING CENTER KIT . . . . . . . . . . 1
(Includes an inner cup, a spring and
an outer cup.)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
(Items not shown)
PRINTED IN U.S.A.
Hydraulics
552/553 Dynalift
Priority Valve/Flow Divider Breakdown
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
LS
T
P
EF
PP
CF
2
Ref.
No.
00
01
Part
No.
L64179
L97654
PRINTED IN U.S.A.
Description
Qty.
Req.
PRIORITY VALVE (Complete) . . . . 1
RELIEF CARTRIDGE ASY.. . . . . . . 1
Ref.
No.
Part
No.
02
L97658
129
Description
Qty.
Req.
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
(Items not shown)
908459/AP0603
Hydraulics
552/553 Dynalift
Frame Level Valve Breakdown
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
5
2
3
6
4
12
10
11
9
7
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
07
08
1
1
1
1
1
09
10
11
L62320
L65842
L50612
L63476
L97959
L97299
........1
12
L99186
00
L68313
FRAME LEVEL VALVE W/RELIEF . 1
01
02
03
04
05
L99194
L99200
L99201
L99202
L98500
06
L98473
END CAP. . . . . . . . . . . .
OUTER STOP CUP . . . .
SPRING. . . . . . . . . . . . .
INNER STOP CUP. . . . .
SPRING CENTER KIT . .
LOAD CHECK SPRING .
908459AP0603
8
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
130
Description
RELIEF CARTRIDGE. . . . . . . .
CLEVIS PIN . . . . . . . . . . . . . . .
1/16” COTTER PIN . . . . . . . . .
CABLE ADAPTER . . . . . . . . . .
CLEVIS BRACKET. . . . . . . . . .
SEAL KIT . . . . . . . . . . . . . . . . .
(Includes seals for load check,
spool and relief cartridge)
POWER BEYOND SLEEVE . . .
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
...1
PRINTED IN U.S.A.
Hydraulics
552/553 Dynalift
Auxilary Hydraulic Valve Breakdown
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
5
2
3
6
4
10
11
9
7
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L64411
AUXILARY HYD. VALVE W/RELIEF 1
01
02
03
04
05
L99194
L99200
L99201
L99202
L98500
06
L98473
END CAP. . . . . . . . . . . .
OUTER STOP CUP . . . .
SPRING. . . . . . . . . . . . .
INNER STOP CUP. . . . .
SPRING CENTER KIT . .
LOAD CHECK SPRING .
PRINTED IN U.S.A.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
8
Ref.
No.
Part
No.
07
08
L62320
L65842
L50612
L63476
L97959
L97299
09
10
11
Description
Qty.
Req.
RELIEF CARTRIDGE. . . . . . . .
CLEVIS PIN . . . . . . . . . . . . . . .
1/16” COTTER PIN . . . . . . . . .
CABLE ADAPTER . . . . . . . . . .
CLEVIS BRACKET. . . . . . . . . .
SEAL KIT . . . . . . . . . . . . . . . . .
(Includes seals for load check,
spool and relief cartridge)
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
........1
131
908459/AP0603
Hydraulics
552/553 Dynalift
Steer Cylinders Breakdown
552: S/N 1075 and Up
553: S/N 4832 and Up
552: Thru S/N 1074
553: Thru S/N 4831
1
1
2
2
Ref.
No.
01
Part
No.
L500540
L500539
02
L500943
Description
Qty.
Req.
STEER CYLINDER . . . . . . . . . . . . 1
STEER CYLINDER BOLT . . . . . . . 4
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
01
L98444
L98445
L98565
02
Qty.
Req.
STEER CYLINDER ASSEMBLY . . . 1
CYLINDER BOLT . . . . . . . . . . . . . 5
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
NOTE: Quantities are per axle
NOTE: Quantities are per axle
908459AP0603
Description
132
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Steer Valve Breakdown
1
2
3
4
Ref.
No.
01
02a
03
Part
No.
L69747
L500770
NSS
04
L99907
L63602
PRINTED IN U.S.A.
Description
Qty.
Req.
STEER SELECT VALVE. . . . . . . . . 1
(Includes all items shown)
COIL 12VDC W/CONNECTOR. . . . 2
NUT . . . . . . . . . . . . . . . . . . . . . . . . 2
(Included with item 1)
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
See note b
See note c
Ref.
No.
Part
No.
L68711
Description
Qty.
Req.
-- ITEMS NOT SHOWN -HARNESS, WIRE ADAPTER . . . . . 1
a
552: S/N 1051 and Up
553: S/N 4350 and Up
b
c
Used with valves that have a round coil
Used with vavles that have a square coil
133
908459/AP0603
Hydraulics
552/553 Dynalift
Steer Motor Breakdown
1
LS
L
T
R
P
2
Ref.
No.
Part
No.
01
L68713
L66753
L64523
02
L500962
L99002
L97671
908459AP0603
Description
Qty.
Req.
STEERING CONTROL UNIT . . . . . 1
See note a
See note b
See note c
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
See note a
See note b
See note c
Ref.
No.
Part
No.
Description
Qty.
Req.
NOTE: Field service is limited to seals replacement.
a
552: S/N 1057 and Up
553: S/N 4519 and Up
b
552: S/N 1012 Thru S/N 1056
553: S/N 3178 Thru S/N 4518
c
552: Thru S/N 1011
553: Thru S/N 3177
134
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Brake Valve Breakdown
1
2
REPAIR KIT
3
7
4
5
6
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
06
07a
L98535
L98537
a
Repair kit includes seals, cups, return spring,
second arm piston, and snap ring. Piston is not
included or sold seperately.
00
L63363
BRAKE VALVE ASY. (Complete). . . 2
01
02
L98532
L98533
L98534
NSS
L98543
L98536
BAIL WIRE. . . . . . . . . . .
COVER . . . . . . . . . . . . .
DIAPHRAM GASKET . .
BODY
TUBE SEAT (not shown)
RUBBER BOOT . . . . . . .
03
04
05
PRINTED IN U.S.A.
........1
........1
........1
........1
........1
135
Description
Qty.
Req.
PUSH ROD . . . . . . . . . . . . . . . . . . 1
REPAIR KIT . . . . . . . . . . . . . . . . . . 1
908459/AP0603
Hydraulics
552/553 Dynalift
Joystick Breakdown
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
USED WITH
JOYSTICK #L68775
USED WITH
JOYSTICK #L62553
29
1
28
27
30
26
28
2
25
3
24
32
23
13
4
17
22
5
21
33
6
20
7
19
14
8
18
17
9
10
31
16
15
11
12
908459AP0603
136
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Joystick Breakdown
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
00a
00b
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
19
Part
No.
L68775
L62553
Description
Qty.
Req.
JOYSTICK W/GATE (Complete) . . . 1
JOYSTICK (Complete) . . . . . . . . . . 1
Note: Quantities shown are for one joystick.
L46572
KNOB . . . . . . . . . . . . . . . . . . . . . . 1
L96852
BOOT . . . . . . . . . . . . . . . . . . . . . . 1
L96853
RETAINER . . . . . . . . . . . . . . . . . . . 1
L98044
HANDLE, ROD . . . . . . . . . . . . . . . 1
L50151
1/2” FLAT WASHER . . . . . . . . . . . . 1
L96851
RETAINER RING . . . . . . . . . . . . . . 1
L50082
5/8”-11 JAM NUT . . . . . . . . . . . . . . 1
L98042
HANDLE ADAPTER . . . . . . . . . . . . 1
L96993
CAM PLATE. . . . . . . . . . . . . . . . . . 1
L500949
PIVOT RACE . . . . . . . . . . . . . . . . . 1
L500950
PIVOT PIN . . . . . . . . . . . . . . . . . . . 1
L500951
PIVOT BALL . . . . . . . . . . . . . . . . . 1
L96994
MOUNTING PLATE . . . . . . . . . . . . 1
L96995
MOUNTING PLATE . . . . . . . . . . . . 1
NSS
BODY . . . . . . . . . . . . . . . . . . . . . . 1
L96999
SPACER . . . . . . . . . . . . . . . . . . . . 4
L97583
RETAINING RING . . . . . . . . . . . . . 8
NSS
SPOOL . . . . . . . . . . . . . . . . . . . . . 4
L97585
SHIM PAC . . . . . . . . . . . . . . . . . A/R
(Includes sizes: 0.01, 0.02, 0.06)
PRINTED IN U.S.A.
Ref.
No.
20
21
22
23
24
25
26
27
28
29
30
Part
No.
L97584
L96928
NSS
L97579
L97580
L97581
L500945
L500944
L50139
L500947
L500946
31
L96997
32
L97631
33
L97582
a
b
c
This joystick is used for Tilt and Level operations.
This joystick is used for Boom Lift and Extend.
Used only with joystick #L68775.
137
Description
Qty.
Req.
SPRING 0.341ODX.051WD . . . . . . 4
SPRING 0.771ODX0.55WD . . . . . . 4
SPRING RETAINER. . . . . . . . . . . . 4
PLUNGER PIN. . . . . . . . . . . . . . . . 4
PLUNGER GUIDE . . . . . . . . . . . . . 4
SEAL KIT . . . . . . . . . . . . . . . . . . . . 4
SPACER, JOYSTICK GATE . . . . . . 4
GATE, JOYSTICK CONTROLLER . 1
1/4” LOCK WASHER . . . . . . . . . . . 4
1/4”-20X3/4” SOCKET HD BOLT . . 4
1/4”-20 SOCKET HD BOLT . . . . . . 4
-- KITS-PIVOT BALL ASSEMBLY . . . . . . . . 1
PLUNGER GUIDE ASSEMBLY . . . 4
SPOOL ASSEMBLY . . . . . . . . . . . . 4
(Includes items 17-20 & 22)
908459/AP0603
552/553 Dynalift
Hydraulics
Auxilary Hydraulic Joystick Breakdown
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
1
25
2
24
27
14
23
3
18
4
13
22
21
28
5
12
20
19
26
6
17
18
7
15
16
8
9
10
908459AP0603
11
138
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
(552: S/N 1057 and Up; 553: S/N 4519 and Up)
Ref.
No.
00
Part
No.
L60302
Qty.
Req.
AUXILARY JOYSTICK (Complete) 1
01
02
L97634
L97633
L96920
L50151
L96851
L96911
L50082
651270
L97041
L96933
NSS
NSS
L97042
NSS
L500769
NSS
KNOB . . . . . . . . . . .
BOOT . . . . . . . . . . .
RETAINER . . . . . . .
1/2” FLAT WASHER .
RETAINER RING . . .
HANDLE, ROD . . . .
5/8”-11 JAM NUT . . .
1/4”-20 JAM NUT . . .
ROCKER ARM. . . . .
BUTTON . . . . . . . . .
PIN . . . . . . . . . . . . .
RETAINING RING . .
BOTTOM PLATE . . .
TOP PLATE . . . . . . .
BOOT PLATE. . . . . .
BODY . . . . . . . . . . .
03
04
05
06
07
08
09
10
11
12
13
14
15
PRINTED IN U.S.A.
Description
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
1
2
1
2
1
2
1
1
1
1
Ref.
No.
16
17
18
19
Part
No.
L96999
NSS
L96923
L97585
20
21
22
23
24
25
L96924
L96928
NSS
L97579
L97580
L96929
26
L96932
27
L97631
28
L96931
139
Description
Qty.
Req.
SPACER . . . . . . . . . . . . . . . . . . . . 4
SPOOL . . . . . . . . . . . . . . . . . . . . . 4
RETAINING RING . . . . . . . . . . . . . 4
SHIM PAC . . . . . . . . . . . . . . . . . A/R
(Includes sizes: 0.01, 0.02, 0.06)
SPRING 0.341ODX0.051WD . . . . . 2
SPRING 0.771ODX0.55WD . . . . . . 4
SPRING RETAINER. . . . . . . . . . . . 4
PLUNGER PIN. . . . . . . . . . . . . . . . 4
PLUNGER GUIDE . . . . . . . . . . . . . 4
SEAL KIT . . . . . . . . . . . . . . . . . . . . 2
-- KITS-ROCKER ARM ASSEMBLY . . . . . . 1
PLUNGER GUIDE ASSEMBLY . . . 4
SPOOL ASSEMBLY . . . . . . . . . . . . 4
(Includes items 17-20 & 22)
908459/AP0603
Hydraulics
552/553 Dynalift
Joystick Breakdown
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
2
3
7
4
7
5
6
8
908459AP0603
140
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Joystick Breakdown
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
Part
No.
Description
Qty.
Req.
Note: Quantities are shown are for one joystick
00
L63126
00
L63345
01a
L63477
L98495
PRINTED IN U.S.A.
BOOM CONTROL JOYSTICK . . . 1
(Boom lift and boom extend)
TILT/FRAME LEVEL JOYSTICK. . . 1
(Carriage Tilt and Frame Level)
KNOB (Used for L63126) . . . . . . . . 1
KNOB (Used for L63345) . . . . . . . . 1
Ref.
No.
Part
No.
02
03
04
05
06
07
08
L98605
L98494
L98496
L98497
L98498
NSS
Note b
a
Knob must be purchased seperately, it does not
come with the joystick.
b
Refer to page 114 “Joystick Group” for part
numbers of control cables.
141
Description
HANDLE . . . . . . . . .
BOOT . . . . . . . . . . .
BUSHING . . . . . . . .
LOCK SCREW. . . . .
CABLE CLAMP . . . .
HOUSING COVERS
CONTROL CABLES.
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
2
2
2
4
908459/AP0603
Hydraulics
552/553 Dynalift
(552: Thru S/N 1056; 553: Thru S/N 4518)
1
2
3
4
908459AP0603
142
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
(552: Thru S/N 1056; 553: Thru S/N 4518)
Ref.
No.
Part
No.
Description
Qty.
Req.
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63127
AUXILARY FUNCTION JOYSTICK. 1
(Auxliary Hydraulic Functions)
03
04
L98877
Note a
01
02
L98495
L98604
KNOB . . . . . . . . . . . . . . . . . . . . . . 1
HANDLE . . . . . . . . . . . . . . . . . . . . 1
a
Refer to page 114 “Joystick Group” for part
number of control cable.
PRINTED IN U.S.A.
143
BOOT . . . . . . . . . . . . . . . . . . . . . . 1
CONTROL CABLE . . . . . . . . . . . . . 1
908459/AP0603
Hydraulics
552/553 Dynalift
Dual Relief Valve Breakdown
(552: S/N 1042 and Up; 553: S/N 4207 and Up)
1
3, 4, 5
6
2
7
Ref.
No.
01
02
03
04
Part
No.
Description
L71066
L500329
L500330
L500331
COMPLETE ASSEMBLY
RELIEF VALVE . . . . . . .
HEX PLUG. . . . . . . . . . .
CHECK POPPET . . . . . .
908459AP0603
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
05
06
07
L500332
L500333
L500334
.
.
.
.
.
.
.
.
1
2
2
2
144
Description
Qty.
Req.
SPRING. . . . . . . . . . . . . . . . . . . . . 2
PLUG. . . . . . . . . . . . . . . . . . . . . . . 2
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Dual Relief Valve Breakdown
(552: Thru S/N 1041; 553: Thru S/N 4206)
1
2
3
4
Ref.
No.
01
02
Part
No.
L64658
L97657
PRINTED IN U.S.A.
Description
Qty.
Req.
COMPLETE ASSEMBLY . . . . . . . . 1
CHECK VALVE . . . . . . . . . . . . . . . 2
Ref.
No.
Part
No.
03
04
L97656
L97658
145
Description
Qty.
Req.
CARTRIDGE . . . . . . . . . . . . . . . . . 2
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
908459/AP0603
Hydraulics
552/553 Dynalift
Frame Level Cylinder Breakdown
1
7
2
6
5
3
8
4
9
11
10
12
908459AP0603
146
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Frame Level Cylinder Breakdown
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63015
FRAME LEVEL CYL. (Complete) . . 1
01
02
03
04
05
06
L98503
L63016
L98547
L99857
L98507
L98550
ROD . . . . . . . . . . . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . 1
HEAD GLAND CAP . . . . . . . . . . . . 1
5/16”-18x1/4” SET SCREW . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
Ref.
No.
Part
No.
07
08
09
10
11
L99405
L64367
NSS
L98509
L70495
L97889
L98506
12
147
Description
Qty.
Req.
1-1/4”-12 UNF LOCKNUT. . . . .
BUSHING 2.0X2.25X2.0” . . . . .
TUBE WELDMENT . . . . . . . . .
OIL LINE TUBE ASSEMBLY. . .
COUNTER BALANCE VALVE .
SEAL KIT (CBV) . . . . . . . . . . .
CYLINDER SEAL KIT. . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
2
1
1
908459/AP0603
Hydraulics
552/553 Dynalift
Lift Cylinder Breakdown
1
6
5
4
2
3
7
9
8
10
908459AP0603
148
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Lift Cylinder Breakdown
Ref.
No.
00
01
02
03
04
05
Part
No.
L63199
Description
Qty.
Req.
LIFT CYLINDER (Complete). . . . . . 2
Note: Quantities shown are for one cylinder.
L98518
ROD WELDMENT . . . . . . . . . . . . . 1
L98520
HEAD GLAND CAP . . . . . . . . . . . . 1
L99857
5/16”-18X1/4” SET SCREW . . . . . . 1
L98522
HEAD GLAND . . . . . . . . . . . . . . . . 1
L98523
PISTON . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
Ref.
No.
Part
No.
06
07
08
L99405
NSS
L98519
09
L64175
L97889
L98521
10
149
Description
Qty.
Req.
1-1/4”-12 UNF LOCKNUT. . . . .
TUBE WELDMENT . . . . . . . . .
OIL LINE TUBE ASSEMBLY. . .
(includes nuts and ferrules)
SEAL KIT (CBV) . . . . . . . . . . .
...1
...1
...1
...1
...1
...1
908459/AP0603
Hydraulics
552/553 Dynalift
Slave Cylinder Breakdown
2
1
7
6
5
4
3
8
9
10
908459AP0603
150
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Slave Cylinder Breakdown
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63014
SLAVE CYLINDER (Complete). . . . 1
01
02
03
04
05
L98524
L63018
L99857
L98513
L98528
ROD WELDMENT . . . . . . .
BUSHING . . . . . . . . . . . . .
5/16”-18X1/4” SET SCREW
HEAD GLAND CAP . . . . . .
HEAD GLAND . . . . . . . . . .
PRINTED IN U.S.A.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
Ref.
No.
Part
No.
06
07
08
09
10
L98529
L500668
L63017
NSS
L98527
151
Description
Qty.
Req.
PISTON . . . . . . . . . . . . . . . . . .
1-1/8”-12 UN LOCKNUT. . . . . .
BUSHING . . . . . . . . . . . . . . . .
TUBE WELDMENT . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
908459/AP0603
Hydraulics
552/553 Dynalift
Tilt Cylinder Breakdown
2
1
7
6
5
4
3
8
9
10
11
908459AP0603
12
152
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Tilt Cylinder Breakdown
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63013
SLAVE CYLINDER (Complete). . . . 1
01
02
03
04
05
06
07
L98545
L63018
L99857
L98547
L99866
L98550
L99405
ROD WELDMENT . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . 1
5/16”-18X1/4” SET SCREW . . . . . . 1
HEAD GLAND CAP . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . 1
1-1/4”-12 UN LOCKNUT. . . . . . . . . 1
PRINTED IN U.S.A.
Ref.
No.
Part
No.
08
09
10
11
NSS
L63017
L70495
L97889
L98548
12
L98551
153
Description
Qty.
Req.
TUBE WELDMENT . . . . . . . . .
BUSHING . . . . . . . . . . . . . . . .
SEAL KIT (CBV)
HYDRAULIC LINE ASSY. . . . . .
...1
...1
...1
...1
...1
908459/AP0603
Hydraulics
552/553 Dynalift
Boom Extend Cylinder Breakdown
1
2
7
6
8
5
4
3
9
11
10
12
908459AP0603
154
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Boom Extend Cylinder Breakdown
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63012
EXTEND CYLINDER (Complete) . . 1
01
02
03
04
05
06
L98511
L63018
L99857
L98513
L99515
L98516
ROD WELDMENT . . . . . . . . . . . . . 1
BUSHING . . . . . . . . . . . . . . . . . . . 1
5/16”-18X1/4” SET SCREW . . . . . . 1
HEAD GLAND CAP . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
Ref.
No.
Part
No.
07
08
09
10
L500668
L63017
NSS
L48868A
L96838
L98517
L98558
11
12
155
Description
Qty.
Req.
1-1/8”-12 UN LOCKNUT. . . . . .
BUSHING . . . . . . . . . . . . . . . .
TUBE WELDMENT . . . . . . . . .
SEAL KIT (CBV)
HYDRAULIC LINE ASSY. . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
...1
...1
908484/AP0303
Hydraulics
552/553 Dynalift
Fork Shift Cylinder Breakdown
1
3
4
2
6
5
Ref.
No.
01
02
03
Part
No.
L68337
L500763
L500762
L500761
908459AP0603
Description
Qty.
Req.
COMPLETE ASSEMBLY
ROD WELDMENT . . . . . . . . . . . . . 1
HEAD GLAND . . . . . . . . . . . . . . . . 1
PISTON . . . . . . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
04
05
06
L500367
NSS
L500370
156
Description
Qty.
Req.
3/4”-16 UNF LOCKNUT . . . . . . . . . 1
TUBE WELDMENT . . . . . . . . . . . . 1
SEAL KIT . . . . . . . . . . . . . . . . . . . . 1
PRINTED IN U.S.A.
552/553 Dynalift
Hydraulics
Rotate Carriage Cylinder Breakdown
1
9
2
8
7
6
5
3
4
10
12
11
Ref.
No.
Part
No.
Description
Qty.
Req.
00
L63594
ROTATE CYLINDER (Complete) . . 1
01
02
03
04
05
06
L99168
L63593
L99169
L99857
L99171
L99174
ROD WELDMENT . . . . . . .
BUSHING . . . . . . . . . . . . .
HEAD GLAND CAP . . . . . .
5/16”-18X1/4” SET SCREW
HEAD GLAND . . . . . . . . . .
SPACER, ROD. . . . . . . . . .
PRINTED IN U.S.A.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
1
1
Ref.
No.
Part
No.
07
06
09
10
L99175
L98921
L500367
L64175
L97889
NSS
L99170
11
12
157
Description
Qty.
Req.
SUPPORT WASHER . . . . . . . .
PISTON . . . . . . . . . . . . . . . . . .
3/4”-16 UN LOCKNUT . . . . . . .
SEAL KIT (CBV)
TUBE WELDMENT . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
1
1
1
1
...1
...1
908459/AP0603
Attachments
552/553 Dynalift
Standard Carriage Attachment Group
5
3
2
1
4
3
5
908459/AP0603
158
PRINTED IN U.S.A.
552/553 Dynalift
Attachments
Standard Carriage Attachment Group
Ref.
No.
01
02
03
04
04
04
Part
No.
L99192
L99193
L66615
L42871
L63319
L63320
L47263
L47265
L61017
PRINTED IN U.S.A.
Description
Qty.
Req.
STD. CARR. WELD. 48”. . . . . . . .
STD. CARR. WELD. 66”. . . . . . . .
CAPACITY PLATE . . . . . . . . . . . .
POPRIVET . . . . . . . . . . . . . . . . .
FORK SHAFT BAR 51-1/2 O.A.L..
FORK SHAFT BAR 68-1/2 O.A.L..
FORK 2X5X48 . . . . . . . . . . . . . . .
FORK 2X5X60 . . . . . . . . . . . . . . .
BRICK FORK2X4X48. . . . . . . . . .
.
.
.
.
.
.
.
.
.
1
1
1
4
1
1
2
2
2
Ref.
No.
Part
No.
04
04
04
05
L61001
L400929
L66406
L400425
L50273
L520005
159
Description
Qty.
Req.
BLOCK FORK 2X2X48. . . . . .
FORK,1 3/4X5X48 . . . . . . . . .
FORK, 2 1/4X4X48 . . . . . . . .
RETAINER . . . . . . . . . . . . . . .
CAPSCREW 3/8-16X2-3/4 . .
NYLON INSERT NUT 3/8-16.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
4
2
2
2
2
2
908459/AP0603
Attachments
552/553 Dynalift
Shift Fork Carriage Attachment Group
1
19
20
18
14
15
13
2
11
15
9
12
16
17
9
10
8
7
6
5
2
3
4
908459/AP0603
160
PRINTED IN U.S.A.
552/553 Dynalift
Attachments
Shift Fork Carriage Attachment Group
Ref.
No.
01
02
03
04
05
06
07
08
09
10
11
12
13b
14b
15
16
Part
No.
L500215
L42871
L66615
L50519
L400425
L50333
L66919
L66931
L50875
Note a
L63715
L50242
L63716
L520004
NSS
NSS
L66918
L68337
PRINTED IN U.S.A.
Description
FORK SHIFT CARRIAGE. . . . .
1/8” POP RIVET. . . . . . . . . . . .
NAME PLATE . . . . . . . . . . . . .
FORK SHAFT WASHER . . . . .
3/4”-10X3” BOLT . . . . . . . . . . .
FORK SHAFT, 50” . . . . . . . . . .
FORK SLIDE PLATE . . . . . . . .
3/4”-10X1-1/2” BOLT . . . . . . . .
FORK SLIDE COUPLER . . . . .
TWIN CUSHION TOP PLATE. .
5/16”-18X2-1/4” BOLT . . . . . . .
TWIN HOSE CUSHION . . . . . .
COUPLER, MALE . . . . . . . . . .
COUPLER, FEMALE . . . . . . . .
CYLINDER MOUNT . . . . . . . . .
FORK SHIFT CYLINDER . . . . .
Qty.
Req.
Ref.
No.
Part
No.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
17
18
19
20
L50562
L63143
L66950
L66949
a
For 4” wide forks use P/N L66921.
For 5” wide forks use P/N L66948.
b
Sold as a set. Order part #L65273 Quick Couplers
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
4
1
3
1
1
1
2
1
1
2
2
1
2
1
1
2
1
00
00
00
00
00
00
161
L47263
L47265
L68331
L61017
L400929
L66406
Description
Qty.
Req.
3/4”-10X4” BOLT . . . . . . . . . . . . .
ADAP -8ORM -6JICM W/.06 ORF
HOSE -6 A6/A6 59” . . . . . . . . . . .
HOSE -6 A6/A6 56” . . . . . . . . . . .
-- ITEMS NOT SHOWN -(FORKS)
FORK, 2X5X48 . . . . . .
FORK, 2X5X60 . . . . . .
FORK, 2X5X72 . . . . . .
BRICK FORK, 2X4X48.
FORK, 1 3/4X5X48 . . .
FORK, 2 1/4X4X48 . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
1
1
2
2
2
2
2
2
908459/AP0603
Attachments
552/553 Dynalift
Rotate Carriage Attachment Group
11
10
8
5
14
7
1
10
2
11
13
3
12
9
6
4
12
908459/AP0603
162
PRINTED IN U.S.A.
552/553 Dynalift
Attachments
Rotate Carriage Attachment Group
Ref.
No.
01
02
03
04
05
06
07
08
09
Part
No.
L63952
NSS
L50801
L520005
L50205
L61287
L63968
L50892
L520019
L50273
L520005
L99225
L99224
L64367
L61709
L50261
L66615
L42871
L63969
L50294
L520019
L50273
L520005
Description
Qty.
Req.
ROTATE PLATE WELD (IncI. 2) . . .
ROTATE PIN (Welded To Item 1). .
CAPSCREW 3/8-16X4 . . . . . . . . .
NYLON INSERT NUT 3/8-16. . . . .
CASTELLATED NUT 2-12 . . . . . . .
WASHER . . . . . . . . . . . . . . . . . . .
BUTT END PIVOT PIN. . . . . . . . . .
CAPSCREW 1/2-13X4 . . . . . . . . .
CAPSCREW 3/8-16X2-3/4 . . . . . .
ROT. CARR. WELD. 48” (IncI.6,7).
ROT. CARR. WELD. 66” (IncI.6,7).
BUSHING . . . . . . . . . . . . . . . . . . .
SLIDE PAD 3X4 . . . . . . . . . . . . . . .
CAPSCREW 3/8-16X1-1/2 . . . . . .
CAPACITY PLATE . . . . . . . . . . . . .
POPRIVET . . . . . . . . . . . . . . . . . .
ROD END PIVOT PIN . . . . . . . . . .
CAPSCREW 1/2-13X3-1/2 . . . . . .
CAPSCREW 3/8-16X2-3/4 . . . . . .
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3
6
1
4
1
1
1
1
1
Ref.
No.
Part
No.
10
L63319
L63320
L50273
L520005
L400425
L61307
L63594
11
12
13a
14
L47263
L47265
L68331
L61017
L61001
L400929
L66406
a
Qty.
Req.
FORK SHAFT BAR 51-1/2” LG.
FORK SHAFT BAR 68-1/2’ LG..
CAPSCREW 3/8-16X2-3/4 . . .
NYLON INSERT NUT 3/8-16. .
RETAINER . . . . . . . . . . . . . . . .
SPACER . . . . . . . . . . . . . . . . .
ROTATE CYLINDER . . . . . . . .
FORKS
FORK, 2X5X48 . . . . . . . . . . . .
FORK, 2X5X60 . . . . . . . . . . . .
FORK, 2X5X72 . . . . . . . . . . . .
BRICK FORK, 2X4X48. . . . . . .
BLOCK FORK, 2X2X48 . . . . . .
FORK, 1 3/4X5X48 . . . . . . . . .
FORK, 2 1/4X4X48 . . . . . . . . .
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
2
2
2
1
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
2
2
4
2
2
Hoses and fittings are listed in the “Items Not
Shown” section below.
-- ITEMS NOT SHOWN -L51968
L63344
L63143
L65273
PRINTED IN U.S.A.
Description
163
ADAP, -6ORM -6JICM 90DEG
HOSE, -6 A8/A6 20” . . . . . . . .
ADAP, -8ORM -6JICM STR. . .
(with orifice)
HYDRAULIC COUPLER SET.
....2
....2
....2
....1
908459/AP0603
Attachments
552/553 Dynalift
Boom Attachment Group
1
8’ Truss Boom
26
25
2
5’ Jib Boom
24
8
7
Hydraulic Winch
With Brake
27
6
23
19 18
17
15
16
14
11
4
3
13
9
22
21
20
12
5
10
908459/AP0603
164
9
PRINTED IN U.S.A.
552/553 Dynalift
Attachments
Boom Attachment Group
Ref.
No.
01
02
03
04
05
06
07d
08d
09
10
11a
12
13
14
15
16
17
18
19
20b
Part
No.
L99237
L500214
L64294
L64660
L50841
L520003
L444004
NSS
NSS
L445002
L82358
100963
L50286
L520019
L444008
L400398
L50815
100076
L520004
L65338
L66946
Description
Qty.
Req.
8’ TRUSS BOOM WELDMENT. .
5’ JIB BOOM WELDMENT . . . .
HOSE -8 A8/A8 53” . . . . . . . . . .
ADAP -8ORM -8JICM RUN TEE
1/4-20”X2” BOLT . . . . . . . . . . . .
1/4”-20 NYLON INSERT NUT . .
ADAP -8ORM -8JICM STR. . . . .
COUPLER, MALE . . . . . . . . . . .
COUPLER, FEMALE . . . . . . . . .
ADAP -8ORM -8JICM 90 DEG . .
RELIEF VALVE . . . . . . . . . . . . .
HYDRAULIC WINCH . . . . . . . . .
1/2”-13X1-3/4” GR 8 BOLT . . . . .
1/2-13 NYLON INSERT NUT . . .
ADAP -10ORM -8JICM. . . . . . . .
HOSE -6 A8/A8 18.5” . . . . . . . . .
5/16”X2-1/2” BOLT . . . . . . . . . . .
PIN, TRUSS WINCH . . . . . . . . .
WINCH SHEAVE . . . . . . . . . . . .
3/8”X60’ WINCH CABLE . . . . . .
(Includes hook and swivel)
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
1
1
2
1
2
2
2
1
1
2
1
1
6
6
2
2
2
1
2
1
1
Ref.
No.
Part
No.
Description
21
22
23
24
25
26
27c
L50371
L50147
L60451
L61411
L50380
L50152
L446017
3/8”X2-1/2” BOLT . . . . . . . .
3/8” LOCK WASHER . . . . .
WINCH BALL . . . . . . . . . . .
PINTLE HOOK. . . . . . . . . .
1/2”-20X1-1/4” GR 8 BOLT .
1/2” LOCK WASHER . . . . .
ADAP -8JICFS -8JICM 90 .
a
Used 5’ truss booms after attachment
serial number 11182. The winch on 5’ truss
booms before attachment serial number 11183
have been discontinued, you must purchase a
boom and a winch.
b
Used with 5’ truss booms with winch.
c
Not used on some attachments.
d
Sold as a set. Order part #L65273 Quick Couplers
L500222
PRINTED IN U.S.A.
165
Qty.
Req.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
.
2
2
1
1
4
4
2
-- ITEMS NOT SHOWN -AUGER, ADAPTER PLATE . . . . . . 1
908459/AP0603
Attachments
552/553 Dynalift
Bucket Attachment Group
1
2
Ref.
No.
01
Part
No.
L500373
L42871
L66615
908459/AP0603
Description
Qty.
Req.
1.3 CU. YD. BUCKET WELDMNT . 1
1/8” POP RIVET . . . . . . . . . . . . . . 4
NAME PLATE . . . . . . . . . . . . . . . . 1
Ref.
No.
Part
No.
02
L63748
L68831
166
Description
Qty.
Req.
WELD ON CUTTING EDGE. . . . . . 1
3/4”X6”X94”
3/4”X6”X98”
PRINTED IN U.S.A.
552/553 Dynalift
Attachments
Notes
PRINTED IN U.S.A.
167
908459/AP0603
Numerical Index
Part
No.
Page
No.
056859
072340
072340
072794
072797
072798
078936
089069
089069
089070
089070
093475
094951
100011
100012
100076
100135
100963
101158
101279
122288
122288
650965
651270
651543
654022
903891
906213
906214
906317
906317
906318
906323
L10151
L10465
L10465
L120038A
L120039
L120041
L120041
L120047
L120047
L120047
L120047
L120054
L120054
L12047
L277013
L277568
L400398
L400425
L400425
L400425
L400929
L400929
L400929
L40417
9
31
33
9
9
9
55
31
33
31
33
10
10
63
35
165
29
165
37
19
7
8
59
139
63
127
6
6
6
6
6
6
6
59
35
87
55
55
55
55
57
57
57
57
1
55
57
79
31
165
159
161
163
159
161
163
33
908459/AP0603
Ref.
No.
00
11
04
00
00
00
03
21
14
21
14
00
00
14
31
17
01
11
17
01
00
00
21
07
10
15
00
00
00
00
00
00
00
20
23
04
00
08
00
15
03
10
14
00
00
05
00
17
27
15
05
03
11
04
00
14
14
552/553 Dynalift
Part
No.
Page
No.
L40496
L40496
L40805
L41179
L41260
L41260
L41261
L41261
L41847
L41847
L41847
L41848
L41848
L41852
L41854
L42342
L42342
L42448
L42871
L42871
L42871
L42871
L43221
L43964
L43965
L441010
L441010
L441010
L442022
L443011
L443011
L443011
L443011
L443011
L443022
L444001
L444001
L444001
L444001
L444002
L444002
L444002
L444002
L444002
L444002
L444002
L444003
L444003
L444003
L444004
L444004
L444004
L444004
L444004
L444004
L444004
L444004
25
27
53
51
25
27
25
27
41
43
47
31
33
33
45
31
59
37
159
161
163
166
45
31
31
101
45
99
45
107
109
119
121
123
121
101
107
109
59
101
103
105
105
111
45
99
109
117
119
103
105
109
119
123
165
25
27
Ref.
No.
01
01
16
02
02
02
03
03
19
11
06
19
05
14
08
38
01
17
02
01
08
01
20
23
22
09
17
22
12
01
01
04
16
04
02
13
13
23
03
15
09
06
09
03
15
23
09
07
08
17
17
14
26
19
06
11
12
Part
No.
Page
No.
L444007
L444008
L444008
L444008
L444008
L444008
L444010
L444010
L444012
L444070
L4445
L4446
L445001
L445001
L445001
L445002
L445002
L445002
L445002
L445002
L445002
L445002
L445002
L445003
L445003
L445003
L445003
L445005
L445006
L445006
L445012
L445014
L445014
L446017
L446017
L446019
L446020
L446026
L446026
L446026
L446026
L446044
L446044
L446048
L446048
L446049
L447005
L44859
L45049
L45049
L45666
L45934
L46572
L46865
L46865
L46865
L46865
59
107
117
119
123
165
107
121
99
59
49
49
101
109
53
101
109
117
119
119
121
165
99
103
107
111
99
115
109
121
99
101
99
165
63
101
53
107
109
117
119
35
35
45
99
65
51
35
63
65
113
53
137
101
124
124
124
168
Ref.
No.
05
07
07
08
06
14
28
15
17
07
01
05
18
19
06
21
12
12
11
26
02
09
18
06
26
05
13
06
27
15
10
01
01
27
17
05
07
06
08
06
07
32
38
16
24
05
22
22
19
18
01
13
01
03
02
02
03
Part
No.
Page
No.
L46865
L46881
L47212
L47263
L47263
L47263
L47265
L47265
L47265
L47275
L47275
L48011
L48011
L48179
L48868A
L49327
L500127
L500129
L500130
L500132
L500134
L500135
L500214
L500215
L500222
L500314
L500314
L500315
L500317
L500329
L500330
L500331
L500332
L500333
L500334
L500356
L500367
L500367
L500368
L500370
L500373
L500446
L500447
L500448
L500451
L500452
L500453
L500454
L500455
L500455
L500456
L500456
L500457
L500458
L500459
L500460
L500461
99
53
53
159
161
163
159
161
163
31
59
57
57
35
155
45
127
127
127
127
127
127
165
161
165
57
57
57
79
144
144
144
144
144
144
79
156
157
124
156
166
25
25
37
73
73
73
73
67
73
67
73
75
75
75
75
75
Ref.
No.
03
20
24
04
00
14
04
00
14
38
01
00
03
07
10
19
18
16
04
04
03
14
02
01
00
07
09
08
15
02
03
04
05
06
07
15
04
09
03
06
01
06
06
08
02
03
04
05
38
06
24
08
01
02
02
02
02
PRINTED IN U.S.A.
552/553 Dynalift
Part
No.
Page
No.
L500462
L500463
L500464
L500465
L500466
L500467
L500468
L500469
L500470
L500471
L500472
L500473
L500474
L500476
L500477
L500478
L500479
L500480
L500481
L500483
L500484
L500485
L500486
L500488
L500489
L500490
L500490
L500491
L500492
L500493
L500494
L500495
L500496
L500496
L500497
L500498
L500499
L50050
L500500
L500501
L500502
L500503
L500504
L500505
L500506
L500507
L500508
L500509
L50051
L50051
L50051
L500510
L500511
L500512
L500513
L500515
L500516
75
75
75
75
75
75
75
75
75
75
75
75
75
75
75
75
75
75
75
67
67
67
67
67
67
63
67
67
67
67
67
67
67
83
67
67
67
35
67
67
67
67
67
67
67
67
67
67
19
23
35
67
67
67
67
67
67
PRINTED IN U.S.A.
Ref.
No.
02
03
05
06
07
08
09
10
11
12
13
14
15
17
17
18
22
23
24
01
02
03
04
05
06
22
09
10
11
12
13
14
15
12
17
18
19
00
20
21
22
23
26
27
28
29
30
32
20
16
37
33
34
35
36
39
40
Numerical Index
Part
No.
Page
No.
L500517
L500518
L500519
L500521
L500522
L500523
L500524
L500525
L500526
L500527
L500528
L500529
L500531
L500532
L500533
L500534
L500535
L500536
L500537
L500538
L500539
L500539
L500540
L500540
L500541
L500542
L500543
L500544
L500546
L500554
L500555
L50056
L50056
L50056
L50056
L50056
L50056
L50056
L50061
L50061
L50061
L500668
L500668
L500673
L50072
L50072
L500761
L500762
L500763
L500768
L500769
L500770
L500771
L500771
L50082
L50082
L50084
67
67
67
67
67
67
67
67
67
83
83
83
83
83
83
83
83
83
83
83
132
63
132
63
63
63
63
63
63
67
67
29
31
35
37
39
41
55
19
29
47
151
155
25
21
35
156
156
156
39
139
133
75
77
137
139
115
Ref.
No.
41
42
43
45
46
49
49
49
50
01
02
03
05
06
07
08
09
10
13
14
01
12
01
12
13
24
20
21
11
44
48
08
14
03
04
24
03
12
03
06
08
07
07
08
04
20
03
02
01
20
14
02
16
05
07
06
16
Part
No.
Page
No.
L50084
L50084
L50086
L50086
L500943
L500944
L500945
L500946
L500947
L500948
L500949
L500950
L500951
L500952
L500953
L500954
L500955
L500956
L500957
L500958
L500959
L500960
L500961
L500962
L50101
L50101
L50139
L50141
L50141
L50141
L50141
L50141
L50141
L50141
L50143
L50145
L50145
L50145
L50145
L50145
L50145
L50147
L50147
L50147
L50147
L50147
L50147
L50147
L50147
L50147
L50150
L50151
L50151
L50151
L50151
L50151
L50152
63
65
91
95
132
137
137
137
137
29
137
137
137
127
127
127
127
127
127
127
127
127
127
134
25
27
137
23
31
39
41
53
89
91
23
19
29
35
41
43
57
13
165
39
59
89
91
93
93
95
35
137
139
23
35
53
165
169
Ref.
No.
04
04
35
21
02
27
26
30
29
05
10
11
12
06
07
02
11
08
12
17
13
20
15
02
04
08
28
07
02
26
02
04
10
04
20
02
00
27
17
13
05
07
22
25
21
11
27
20
23
08
25
05
03
02
06
14
26
Part
No.
Page
No.
L50152
L50152
L50157
L50157
L50157
L50184
L50201
L50202
L50202
L50202
L50202
L50202
L50202
L50205
L50207
L50207
L50207
L50207
L50207
L50208
L50208
L50208
L50211
L50212
L50226
L50226
L50228
L50228
L50228
L50228
L50230
L50230
L50230
L50230
L50230
L50230
L50235
L50242
L50251
L50251
L50251
L50253
L50261
L50261
L50261
L50261
L50273
L50273
L50273
L50273
L50273
L50273
L50275
L50277
L50283
L50286
L50286
21
91
115
63
65
99
63
15
19
21
23
27
31
163
119
123
91
93
95
29
37
39
21
21
87
91
123
53
93
95
23
31
41
45
53
55
35
161
91
93
95
25
35
89
91
93
117
119
121
87
93
97
115
115
99
13
165
Ref.
No.
16
09
15
03
03
05
25
08
21
17
17
05
38
03
00
16
00
04
05
04
13
01
20
18
05
14
15
05
03
06
06
16
09
23
10
11
02
10
25
19
07
09
28
23
32
22
04
13
05
06
12
03
08
03
06
04
12
908459/AP0603
Numerical Index
Part
No.
Page
No.
L50286
L50294
L50319
L50319
L50333
L50367
L50367
L50367
L50367
L50367
L50367
L50371
L50380
L50380
L50403
L50403
L50403
L50417
L50418
L50442
L50442
L50442
L50462
L50468
L50486
L50491
L50519
L50535
L50535
L50545
L50546
L50562
L50567
L50607
L50607
L50609
L50612
L50612
L50612
L50612
L50628
L50629
L50646
L50646
L50655
L50655
L50655
L50667
L50704
L50712
L50712
L50712
L50727
L50741
L50755
L50755
L50755
45
23
51
59
161
13
29
49
57
91
93
165
165
91
115
89
91
31
45
41
43
57
87
59
39
91
161
103
105
123
31
161
23
31
35
59
128
130
91
95
35
17
89
97
19
31
37
51
59
115
63
65
59
99
41
43
45
908459/AP0603
Ref.
No.
10
01
10
11
04
06
00
02
06
26
15
21
25
08
08
23
30
05
07
18
12
16
02
10
22
07
02
04
04
17
13
17
09
38
18
01
02
08
10
16
11
08
03
12
18
26
16
17
12
14
26
19
26
15
24
10
00
552/553 Dynalift
Part
No.
Page
No.
L50815
L50815
L50823
L50835
L50835
L50836
L50841
L50875
L50877
L50877
L50877
L50878
L50878
L50895
L50896
L50896
L50896
L50896
L50952
L50952
L510007
L510008
L510041
L51052
L51060
L51098
L51099
L51243
L514001
L51493
L51591
L51591
L51622
L51674
L51968
L520003
L520003
L520003
L520004
L520004
L520004
L520004
L520004
L520004
L520004
L520004
L520004
L520004
L520004
L520005
L520005
L520005
L520005
L520005
L520005
L520005
L520005
165
53
41
31
35
57
165
161
119
123
95
121
91
107
19
19
31
37
57
59
89
89
35
37
37
55
55
37
19
101
105
35
35
55
163
103
105
15
107
119
121
123
161
165
35
89
91
93
95
115
117
119
121
29
35
39
49
Ref.
No.
16
18
01
18
14
18
05
07
23
10
23
09
18
10
09
18
25
15
07
25
11
10
24
00
00
00
14
00
12
06
02
15
39
00
00
08
08
02
11
22
10
09
12
18
13
10
17
05
03
05
05
12
03
00
26
23
04
Part
No.
Page
No.
L520005
L520005
L520005
L520005
L520005
L520005
L520007
L520007
L520007
L520017
L520019
L520019
L520019
L520019
L520019
L520019
L520019
L52024
L52025
L52025
L52025
L52025
L52025
L52026
L52026
L52026
L52026
L52028
L530003
L530004
L530004
L530004
L54002
L550003
L550003
L561004
L570022
L580005
L580009
L580009
L60253
L60253
L60291
L60302
L60302
L60451
L60492
L60492
L60653
L61001
L61001
L61017
L61017
L61017
L61021
L61085
L61086
57
87
93
93
95
97
23
51
59
31
13
165
21
23
45
53
87
35
23
29
31
37
41
27
29
93
95
91
47
23
41
53
23
41
45
35
89
35
35
51
107
115
55
111
139
165
57
57
63
159
163
159
161
163
57
21
21
170
Ref.
No.
02
06
06
13
26
02
12
13
13
12
03
13
03
04
11
15
02
37
18
00
03
06
20
11
07
07
27
05
10
08
11
11
14
00
00
00
12
19
00
09
14
17
09
06
00
23
13
14
08
04
14
04
00
14
19
13
19
Part
No.
Page
No.
Ref.
No.
L61092
L61136
L61198
L61199
L61200
L61287
L61307
L61411
L61620
L61699
L61699
L61704
L61704
L61708
L61708
L61708
L61708
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61709
L61867
L62132
L62320
L62320
L62459
L62482
L62484
L62553
L62553
L62583
L62715
L62715
L62715
L62715
L62715
L62715
L62715
L62715
L62720
L62720
L62721
L62722
L62722
L62731
L62731
L62732
L62732
L62733
L62733
L62733
L62734
101
53
19
19
19
163
163
165
45
93
95
87
89
87
89
91
93
163
87
87
89
89
89
91
93
95
45
33
130
131
29
103
31
111
137
9
87
87
89
89
89
91
93
95
41
43
43
41
43
89
93
89
93
87
91
93
89
04
25
07
14
15
03
12
24
18
26
04
17
20
11
20
23
27
07
15
16
15
18
20
28
21
09
07
06
07
07
03
02
15
02
00b
00
12
19
17
19
23
24
16
11
05
03
03
04
03
20
28
22
29
14
29
18
16
PRINTED IN U.S.A.
552/553 Dynalift
Part
No.
Page
No.
L62734
L62734
L62741
L62814
L62831
L62834
L62840
L62840
L62842
L62842
L62842
L62926
L62933
L62949
L630001
L630003
L630004
L63005
L63006
L63009
L63009
L63012
L63012
L63012
L63013
L63013
L63013
L63013
L63014
L63014
L63014
L63015
L63015
L63016
L63016
L63017
L63017
L63017
L63017
L63017
L63017
L63017
L63017
L63017
L63018
L63018
L63018
L63018
L63018
L63024
L63032
L63044
L63056
L63078
L63099
L63099
L63114
93
95
35
49
45
27
125
27
25
27
99
35
27
33
47
47
47
95
93
115
65
121
155
87
119
153
89
97
119
151
87
115
147
115
147
117
151
153
155
87
89
91
95
97
119
121
151
153
155
87
89
65
87
59
87
91
65
PRINTED IN U.S.A.
Ref.
No.
17
10
33
06
03
18
05
19
12
14
07
36
00
10
03
04
02
02
02
12
02
01
00
24
19
00
26
08
16
00
26
01
00
11
02
02
08
09
08
08
08
16
22
05
15
18
02
02
02
01
09
18
03
19
02
21
12
Numerical Index
Part
No.
Page
No.
Ref.
No.
Part
No.
Page
No.
L63115
L63115
L63125
L63125
L63126
L63127
L63127
L63128
L63128
L63128
L63129
L63131
L63131
L63132
L63142
L63143
L63143
L63143
L63143
L63145
L63145
L63153
L63156
L63156
L63157
L63158
L63166
L63166
L63167
L63167
L63168
L63169
L63172
L63173
L63199
L63199
L63199
L63200
L63202
L63203
L63215
L63216
L63216
L63217
L63222
L63222
L63230
L63234
L63239
L63248
L63261
L63262
L63263
L63264
L63265
L63269
L63272
115
65
109
128
141
113
143
113
113
115
59
87
91
17
33
101
115
161
163
119
123
93
95
95
93
93
91
95
91
95
95
91
35
91
117
149
87
91
59
59
45
101
45
45
63
65
35
65
93
47
51
51
59
59
23
23
119
13
20
29
01
00
03
00
04
06
18
09
05
13
04
00
27
19
18
00
01
01
11
15
18
10
09
34
19
33
20
17
11
04
12
01
00
25
01
09
19
01
10a
21
09
19
18
01
01
25
05
16
15
23
17
19
03
14
L63272
L63272
L63272
L63272
L63272
L63273
L63273
L63273
L63273
L63274
L63274
L63274
L63274
L63275
L63276
L63280
L63284
L63286
L63308
L63308
L63309
L63309
L63314
L63314
L63319
L63319
L63320
L63320
L63326
L63334
L63335
L63335
L63335
L63335
L63344
L63345
L63345
L63345
L63356
L63361
L63363
L63363
L63373
L63379
L63379
L63379
L63380
L63381
L63381
L63382
L63382
L63382
L63382
L63383
L63383
L63384
L63384
121
87
89
89
97
119
121
87
89
117
87
89
97
115
115
65
49
35
101
124
101
99
87
89
159
163
159
163
97
47
19
33
33
33
163
113
113
141
53
43
135
35
35
101
103
105
101
63
65
35
35
63
65
103
105
101
103
171
Ref.
No.
19
06
07
13
06
18
04
09
14
03
07
06
04
10
04
11
00
40
03
01
02
02
10
10
03
10
03
10
10
01
18
00
12
13
00
01
02
00
03
05
00
34
21
26
03
03
17
07
07
29
30
06
06
12
12
22
14
Part
No.
Page
No.
L63384
L63384
L63385
L63385
L63385
L63386
L63386
L63386
L63386
L63387
L63387
L63387
L63387
L63388
L63388
L63388
L63388
L63389
L63389
L63389
L63389
L63389
L63389
L63390
L63390
L63391
L63391
L63391
L63391
L63392
L63392
L63393
L63394
L63395
L63396
L63396
L63397
L63397
L63398
L63398
L63399
L63399
L63400
L63401
L63402
L63402
L63403
L63403
L63403
L63403
L63405
L63405
L63406
L63406
L63406
L63406
L63407
105
99
101
101
115
103
105
63
65
103
105
63
65
103
105
63
65
109
109
119
119
123
123
101
105
109
109
121
121
109
109
109
109
101
101
109
109
117
109
117
53
59
53
109
101
27
103
105
63
65
119
119
101
107
109
99
107
Ref.
No.
14
11
23
24
07
07
07
15
14
13
13
16
15
11
11
16
15
02
03
02
03
02
03
16
15
26
28
11
12
10
11
16
15
12
11
20
04
09
05
08
09
02
08
18
07
17
10
10
15
14
20
21
29
21
21
14
09
908459/AP0603
Numerical Index
Part
No.
Page
No.
L63407
L63407
L63407
L63407
L63407
L63407
L63407
L63408
L63409
L63409
L63420
L63437
L63439
L63439
L63442
L63443
L63453
L63454
L63457
L63458
L63474
L63474
L63476
L63476
L63476
L63476
L63477
L63478
L63490
L63496
L63502
L63503
L63505
L63506
L63509
L63513
L63516
L63519
L63524
L63529
L63530
L63531
L63532
L63536
L63542
L63545
L63545
L63546
L63546
L63547
L63548
L63550
L63550
L63551
L63559
L63560
L63563
107
107
109
109
117
117
119
101
119
119
35
10
55
55
51
51
51
10
113
23
11
8
113
128
130
131
141
21
109
43
101
43
45
43
43
43
43
23
43
13
13
13
13
37
11
37
39
19
49
21
21
33
41
55
23
17
17
908459/AP0603
Ref.
No.
15
16
06
07
10
11
10
19
20
21
00
00
00
16
16
15
15
00
03
13
00
00
07
03
09
09
01
12
17
06
14
05
05
02
01
03
04
14
07
02
02
02
02
07
00
01
12
06
00
14
15
00
00
00
15
07
06
552/553 Dynalift
Part
No.
Page
No.
L63564
L63574
L63593
L63594
L63594
L63595
L63599
L63599
L63599
L63600
L63600
L63601
L63601
L63602
L63606
L63609
L63610
L63610
L63611
L63618
L63629
L63630
L63631
L63632
L63633
L63633
L63636
L63640
L63640
L63647
L63648
L63650
L63651
L63651
L63660
L63661
L63664
L63665
L63674
L63688
L63689
L63690
L63692
L63694
L63694
L63694
L63699
L63699
L63699
L63700
L63715
L63715
L63715
L63715
L63715
L63715
L63716
35
21
157
157
163
49
109
123
123
123
123
123
123
133
33
51
31
33
33
10
35
113
11
11
31
59
57
31
33
33
57
57
35
35
57
10
57
53
31
31
31
10
10
121
87
91
19
31
33
13
119
123
161
87
89
95
123
Ref.
No.
12
02
02
00
13
00
22
07
08
13
14
13
14
04
00
02
10
15
00
00
35
05
00
00
38
01
01
08
16
00
00
09
16
17
15
00
00
21
01
07
37
00
00
17
13
22
19
20
07
10
24
11
09
21
25
25
18
Part
No.
Page
No.
L63716
L63716
L63717
L63717
L63719
L63720
L63725
L63727
L63737
L63738
L63739
L63740
L63741
L63748
L63751
L63752
L63753
L63756
L63756
L63756
L63757
L63764
L63793
L63797
L63797
L63798
L63799
L63801
L63810
L63811
L63813
L63813
L63814
L63815
L63816
L63835
L63837
L63853
L63864
L63864
L63870
L63870
L63872
L63872
L63873
L63874
L63884
L63887
L63894
L63896
L63906
L63913
L63913
L63913
L63919
L63923
L63926
161
95
87
89
87
87
13
17
13
17
13
17
21
166
33
33
33
41
43
45
19
55
21
89
97
45
21
21
29
29
23
37
49
49
49
31
31
49
41
45
23
41
33
49
49
49
23
31
33
13
19
41
43
45
57
89
10
172
Ref.
No.
11
24
20
24
23
22
05
05
08
09
01
01
08
02
00
00
00
25
08
00
00
18
01
02
00
06
02
05
05
01
00
00
09
10
08
38
38
03
00
00
05
00
08
00
00
00
19
38
09
02
00
23
09
00
00
11
00
Part
No.
Page
No.
L63930
L63931
L63931
L63931
L63932
L63932
L63933
L63934
L63935
L63936
L63937
L63938
L63941
L63942
L63943
L63946
L63952
L63957
L63957
L63968
L63969
L64047
L64055
L64090
L64097
L64124
L64124
L64124
L64143
L64143
L64143
L64175
L64175
L64179
L64179
L64196
L64197
L64197
L64197
L64294
L64311
L64311
L64326
L64367
L64367
L64367
L64411
L64411
L64437
L64523
L64523
L64523
L64524
L64524
L64524
L64524
L64572
37
19
31
31
19
31
31
31
31
31
31
31
31
31
65
17
163
89
97
163
163
53
53
33
33
23
51
59
87
89
91
149
157
101
129
59
23
51
59
165
101
101
79
115
147
163
109
131
51
105
134
27
103
105
25
27
57
Ref.
No.
03
17
29
30
16
28
36
31
24
24
32
35
24
24
11
03
01
02
00
04
09
20
25
00
00
10
11
15
18
22
31
09
10
20
00
16
11
12
14
03
08
25
16
02
08
06
25
00
04
01
01
15
16
16
10
13
20
PRINTED IN U.S.A.
552/553 Dynalift
Part
No.
Page
No.
L64646
L64658
L64658
L64660
L64663
L64663
L64664
L64664
L64764
L64788
L64821
L64890
L64970
L64987
L650004
L650004
L650004
L650005
L650012
L650012
L65025
L65097
L65097
L65098
L65098
L65142
L65144
L65224
L65273
L65273
L65338
L65440
L65557
L65568
L65570
L65638
L65638
L65640
L65640
L65842
L65842
L65842
L65920
L65920
L65922
L65922
L65924
L65925
L65926
L65927
L65927
L65927
L65927
L65928
L65928
L65929
L65930
51
109
145
165
35
51
35
51
57
55
57
35
33
49
33
33
51
33
31
33
57
89
97
89
97
45
45
10
161
163
165
10
109
51
51
87
91
87
91
128
130
131
7
9
11
8
7
10
9
11
7
8
9
11
7
11
11
PRINTED IN U.S.A.
Ref.
No.
14
13
01
04
00
08
00
07
04
19
15
09
00
00
01
11
00
11
17
02
12
04
13
05
14
24
22
00
14
00
19
00
24
00
00
27
06
27
03
04
08
08
00
00
00
00
00
00
00
00
00
00
00
00
00
00
00
Numerical Index
Part
No.
Page
No.
L65932
L65932
L65933
L65937
L65942
L65948
L66011
L66042
L66053
L66059
L66110
L66119
L66135
L66138
L66139
L66139
L66156
L66162
L66265
L66360
L66406
L66406
L66406
L66414
L66437
L66437
L66456
L66515
L66547
L66565
L66568
L66568
L66569
L66569
L66581
L66581
L66584
L66585
L66585
L66588
L66595
L66606
L66613
L66615
L66615
L66615
L66615
L66675
L66679
L66709
L66736
L66753
L66753
L66753
L66780
L66782
L66783
7
8
8
9
7
11
31
11
33
27
27
53
35
65
63
65
35
33
53
51
159
161
163
53
31
33
97
53
39
8
7
8
7
9
7
8
7
7
8
39
57
51
7
159
161
163
166
39
39
53
33
105
134
27
95
95
95
Ref.
No.
00
00
00
00
00
00
04
00
00
06
16
12
00
16
09
08
05
00
23
00
04
00
14
20
09
03
09
17
17
00
00
00
00
00
00
00
00
00
00
07
09
06
00
02
01
08
01
06
05
22
11
01
01
15
14
13
12
Part
No.
Page
No.
L66842
L66842
L66843
L66849
L66849
L66850
L66850
L66855
L66877
L66907
L66917
L66918
L66919
L66921
L66931
L66946
L66948
L66949
L66950
L66965
L66976
L66977
L66986
L66993
L66997
L67217
L67226
L67282
L67285
L67308
L67309
L67330
L67452
L67452
L67498
L67499
L67499
L67502
L67502
L67504
L67504
L67507
L67508
L67574
L67575
L67578
L67589
L67607
L67616
L67616
L67617
L67626
L67628
L67629
L67630
L67638
L67655
23
37
19
31
37
19
31
51
55
21
59
161
161
161
161
165
161
161
161
59
39
39
37
37
37
51
39
13
21
21
21
35
53
59
65
63
65
63
65
63
65
65
65
59
59
51
53
55
45
51
57
57
39
39
39
39
39
173
Ref.
No.
00
00
07
30
03
17
29
00
17
18
18
15
05
08
06
20
08
20
19
04
30
32
12
14
08
16
19
01
08
11
06
10
08
06
18
19
18
19
18
19
18
18
18
23
17
16
17
18
12
05
01
01
18
22
20
08
16
Part
No.
Page
No.
L67657
L67674
L67674
L67681
L67681
L67685
L67719
L67720
L67721
L67722
L67723
L67732
L67751
L67756
L67756
L67756
L67804
L67809
L67811
L67813
L67813
L67815
L67821
L67832
L67832
L67832
L67832
L67832
L67832
L67858
L67865
L68003
L68003
L68003
L68006
L68039
L68039
L68052
L68054
L68054
L68056
L68084
L68133
L68134
L68135
L68148
L68149
L68151
L68156
L68171
L68182
L68185
L68186
L68192
L68193
L68200
L68205
55
31
39
31
39
51
9
9
9
9
9
39
53
41
43
57
15
15
15
15
19
15
15
15
19
25
27
37
49
15
13
119
121
97
91
119
123
10
31
51
33
11
41
41
41
39
39
39
39
41
41
41
41
41
41
41
41
Ref.
No.
13
24
10
38
09
15
00
00
00
00
00
14
21
16
14
17
12
11
10
07
13
05
13
06
11
07
10
17
00
09
11
17
06
07
15
25
12
00
33
00
00
00
07
07
07
03
04
02
29
08
12
13
27
06
26
22
15
908459/AP0603
Numerical Index
Part
No.
Page
No.
L68210
L68239
L68239
L68239
L68239
L68239
L68239
L68239
L68268
L68274
L68276
L68277
L68280
L68281
L68288
L68295
L68296
L68304
L68310
L68313
L68313
L68315
L68315
L68331
L68331
L68337
L68346
L68347
L68348
L68348
L68350
L68351
L68351
L68352
L68352
L68353
L68356
L68357
L68358
L68363
L68363
L68364
L68364
L68369
L68370
L68371
L68372
L68373
L68374
L68374
L68375
L68375
L68376
L68376
L68377
L68377
L68437
41
109
119
119
123
123
123
123
41
39
39
39
27
27
39
10
59
49
41
101
130
13
23
161
163
161
87
23
121
91
91
119
123
121
121
109
121
109
91
109
121
109
121
109
109
109
109
109
119
119
119
119
123
123
123
123
15
908459/AP0603
Ref.
No.
21
22
02
03
02
03
07
08
00
31
27
28
09
00
01
00
18
11
10
28
00
09
22
00
14
16
01
19
07
20
01
01
01
11
12
16
08
18
19
28
13
26
14
15
10
11
03
02
20
21
20
21
13
14
13
14
04
552/553 Dynalift
Part
No.
Page
No.
L68438
L68439
L68447
L68447
L68447
L68448
L68449
L68449
L68451
L68459
L68460
L68461
L68463
L68463
L68465
L68466
L68467
L68468
L68510
L68510
L68513
L68516
L68517
L68529
L68531
L68533
L68539
L68539
L68544
L68562
L68563
L68571
L68580
L68588
L68591
L68591
L68592
L68592
L68595
L68595
L68596
L68604
L68614
L68619
L68619
L68638
L68638
L68641
L68643
L68649
L68650
L68651
L68671
L68672
L68673
L68674
L68675
15
19
19
33
37
19
23
41
39
19
19
39
39
39
15
15
39
19
13
23
10
55
55
57
59
59
53
53
57
59
59
51
53
59
37
51
37
51
51
51
51
51
51
45
51
31
33
35
55
95
93
57
11
11
11
11
11
Ref.
No.
01
10
00
01
00
00
21
00
21
08
00
18
08
08
09
03
00
00
09
22
00
06
07
01
23
17
25
25
12
09
19
03
20
08
11
20
09
19
16
16
15
23
21
14
05
06
17
37
18
01
01
09
00
00
00
00
00
Part
No.
Page
No.
Ref.
No.
Part
No.
Page
No.
L68694
L68694
L68694
L68695
L68696
L68697
L68711
L68711
L68711
L68713
L68713
L68713
L68714
L68714
L68744
L68762
L68763
L68763
L68772
L68773
L68774
L68775
L68775
L68777
L68777
L68778
L68778
L68778
L68783
L68783
L68784
L68784
L68794
L68801
L68802
L68803
L68804
L68804
L68805
L68805
L68805
L68806
L68807
L68807
L68808
L68808
L68809
L68809
L68809
L68810
L68811
L68812
L68813
L68814
L68814
L68814
L68814
107
111
127
93
93
93
103
105
133
103
134
25
124
99
93
95
45
99
25
25
25
111
137
33
41
107
111
123
125
99
13
23
115
89
99
99
111
99
103
111
99
107
107
117
107
117
107
107
115
111
111
111
99
107
107
121
121
12
11
00
14
24
08
05
05
00
01
01
13
01
04
01
01
21
25
05
14
00
01
00a
00
00
25
10
05
01
16
09
22
06
09
09
19
12
12
15
13
20
22
17
08
18
09
19
20
07
09
08
07
21
02
03
13
14
L68815
L68815
L68815
L68815
L68816
L68816
L68816
L68816
L68817
L68817
L68824
L68831
L68849
L68866
L68875
L68876
L68876
L68878
L68878
L68881
L68882
L68884
L69166
L69718
L69718
L69734
L69734
L69747
L69747
L69747
L69920
L70146
L70200
L70242
L70468
L70495
L70495
L70649
L71066
L71392
L71392
L71392
L71393
L71393
L71393
L71394
L71637
L72175
L75020
L75906
L75906
L75956
L75956
L76020
L76084
L81690
L82358
107
107
119
123
107
107
119
123
107
119
111
166
63
41
63
115
63
115
63
115
115
63
51
37
51
63
67
103
105
133
99
47
49
91
55
147
153
19
144
13
17
21
13
17
21
19
59
45
53
45
51
37
39
53
53
45
165
174
Ref.
No.
05
23
05
07
04
24
06
08
08
09
04
02
01
21
19
13
27
12
02
09
10
19
05
10
18
18
37
05
05
01
08
09
07
02
06
11
10
22
01
08
02
09
08
02
09
22
24
13
20
00
05
05
00
19
01
14
10
PRINTED IN U.S.A.
552/553 Dynalift
Part
No.
Page
No.
L94746
L96580
L96838
L96851
L96851
L96852
L96853
L96911
L96920
L96923
L96924
L96928
L96928
L96929
L96931
L96932
L96933
L96989
L96993
L96994
L96995
L96997
L96999
L96999
L97041
L97042
L97134
L97135
L97299
L97299
L97489
L97489
L97489
L97579
L97579
L97580
L97580
L97581
L97582
L97583
L97584
L97585
L97585
L97631
L97631
L97633
L97634
L97654
L97656
L97657
L97658
L97658
L97665
L97671
L97889
L97889
L97889
51
127
155
137
139
137
137
139
139
139
139
137
139
139
139
139
139
53
137
137
137
137
137
139
139
139
69
69
130
131
1
45
45
137
139
137
139
137
137
137
137
137
139
137
139
139
139
129
145
145
129
145
124
134
147
149
153
PRINTED IN U.S.A.
Ref.
No.
00
16
10
06
04
02
03
05
02
18
20
21
21
25
28
26
09
02
09
13
14
31
16
16
08
12
10
10
11
11
00
03
04
23
23
24
24
25
33
17
20
19
19
32
27
02
01
01
03
02
02
04
03
02
11
09
10
Numerical Index
Part
No.
Page
No.
L97889
L97956
L97959
L97959
L98042
L98044
L98318
L98318
L98318
L98319
L98320
L98321
L98322
L98323
L98324
L98325
L98331
L98332
L98333
L98334
L98335
L98336
L98337
L98338
L98339
L98341
L98342
L98343
L98344
L98345
L98345
L98346
L98347
L98348
L98349
L98350
L98352
L98353
L98354
L98355
L98355
L98355
L98356
L98360
L98361
L98363
L98364
L98365
L98366
L98367
L98368
L98369
L98370
L98371
L98371
L98372
L98372
157
87
130
131
137
137
67
71
73
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
71
65
71
71
71
71
71
71
69
69
69
63
67
69
69
69
69
69
69
69
69
69
69
69
69
67
69
67
69
Ref.
No.
10
27
10
10
08
04
25
23
07
25
26
20
21
19
16
17
14
15
18
22
24
27
27
01
02
03
05
06
07
17
08
09
10
11
12
13
01
02
04
23
16
05
07
08
09
12
13
14
15
16
17
19
18
07
20
07
21
Part
No.
Page
No.
L98373
L98373
L98374
L98375
L98376
L98377
L98378
L98378
L98379
L98379
L98380
L98380
L98380
L98381
L98381
L98382
L98383
L98384
L98385
L98386
L98387
L98388
L98389
L98390
L98391
L98392
L98393
L98394
L98394
L98395
L98395
L98396
L98396
L98400
L98401
L98404
L98404
L98405
L98406
L98406
L98407
L98414
L98415
L98416
L98417
L98417
L98417
L98418
L98419
L98420
L98421
L98422
L98422
L98423
L98424
L98425
L98426
67
69
69
69
69
69
77
79
77
79
75
77
79
77
79
79
79
79
79
79
79
79
79
79
77
77
77
75
77
75
77
75
77
77
77
75
77
77
75
77
77
77
77
79
67
73
81
81
81
81
81
65
81
81
81
81
81
175
Ref.
No.
47
22
23
03
11
06
01
01
02
02
04
03
03
04
07
05
06
10
09
08
11
04
12
13
14
13
12
21
11
20
10
19
09
08
08
17
06
06
17
06
06
07
07
14
31
01
02
01
03
04
05
10
06
10
11
09
12
Part
No.
Page
No.
L98427
L98428
L98429
L98430
L98430
L98430
L98431
L98432
L98433
L98434
L98435
L98436
L98437
L98438
L98439
L98440
L98441
L98442
L98443
L98444
L98444
L98445
L98445
L98473
L98473
L98494
L98495
L98495
L98496
L98497
L98498
L98500
L98500
L98500
L98502
L98503
L98506
L98507
L98509
L98511
L98513
L98513
L98516
L98517
L98518
L98519
L98520
L98521
L98522
L98523
L98524
L98527
L98528
L98529
L98532
L98533
L98534
81
81
85
65
83
85
85
85
85
85
85
85
85
85
85
85
85
85
65
132
65
132
65
130
131
141
141
143
141
141
141
128
130
131
128
147
147
147
147
155
151
155
155
155
149
149
149
149
149
149
151
151
151
151
135
135
135
Ref.
No.
07
08
01
13
11
02
03
04
05
06
07
08
09
10
11
12
13
14
09
01
13
01
13
06
06
03
01
01
04
05
06
05
05
05
06
01
12
05
10
01
04
04
06
11
01
08
02
10
04
05
01
10
05
06
01
02
02
908459/AP0603
Numerical Index
Part
No.
Page
No.
L98535
L98536
L98537
L98543
L98545
L98547
L98547
L98548
L98550
L98550
L98551
L98555
L98556
L98557
L98558
L98565
L98565
L98568
L98600
L98600
L98601
L98601
L98602
L98602
L98604
L98605
L98647
L98649
L98677
L98678
L98700
L98700
L98709
L98726
L98786
L98787
L98863
L98864
L98864
L98877
L98887
L98891
L98895
L98895
L98896
L98897
L98898
L98899
L98921
L98972
L98973
L98996
L98997
L98998
L99002
L99007
L99008
135
135
135
135
153
147
153
153
147
153
153
59
6
6
155
132
65
45
1
51
1
51
1
51
143
141
55
55
55
55
89
97
35
57
27
27
6
6
8
143
127
127
127
127
127
127
127
127
157
71
71
69
69
69
134
91
91
908459/AP0603
Ref.
No.
06
05
07
04
01
03
04
11
06
06
12
00
00
00
12
02
13
03
00
00
00
00
00
00
02
02
04
04
02
01
01
01
00
11
04
07
00
00
00
03
18
01
05
19
09
09
09
10
06
28
04
23
02
03
02
00
00
552/553 Dynalift
Part
No.
Page
No.
L99009
L99010
L99076
L99124
L99135
L99137
L99141
L99161
L99163
L99168
L99169
L99170
L99171
L99174
L99175
L99182
L99184
L99184
L99186
L99188
L99192
L99193
L99194
L99194
L99196
L99200
L99200
L99201
L99201
L99202
L99202
L99203
L99204
L99205
L99213
L99224
L99225
L99237
L99314
L99315
L99316
L99317
L99318
L99319
L99320
L99321
L99323
L99324
L99325
L99405
L99405
L99405
L99420
L99420
L99425
L99433
L99434
124
39
59
39
91
13
39
51
45
157
157
157
157
157
157
59
1
59
130
69
159
159
130
131
35
130
131
130
131
130
131
71
49
49
71
163
163
165
15
17
21
21
21
21
37
37
21
15
15
147
149
153
1
51
27
53
57
Ref.
No.
03
11
00
22
00
02
00
21
02
01
03
12
05
06
07
00
00
27
12
16
01
01
01
01
37
02
02
03
03
04
04
30
12
13
29
05
05
01
09
10
10
12
07
01
02
00
09
13
09
07
06
07
00
00
09
02
11
Part
No.
Page
No.
L99448
L99449
L99454
L99476
L99515
L99639
L99654
L99847
L99857
L99857
L99857
L99857
L99857
L99857
L99863
L99866
L99907
L99925
L99927
L99928
L99929
L99969
L99978
L99978
L99980
P470079
P47135
P47135
P471370
P471997
39
37
29
1
155
69
39
39
147
149
151
153
155
157
8
153
133
125
125
125
125
65
1
51
95
35
109
121
63
125
176
Ref.
No.
Part
No.
Page
No.
Ref.
No.
00
00
02
00
05
24
00
00
04
03
03
03
03
04
00
05
04
03
03
02
02
09
00
00
01
08
27
15
05
04
PRINTED IN U.S.A.
Torque Specifications
Use these torque values when tightening GEHL hardware (excluding: Locknuts and Self-tapping, Thread-forming and Metal
Screws) unless otherwise specified.
Grade 5
Grade 8
Unified National
Thread
Grade 2
Dry
Lubed
Dry
Lubed
8-32
8-36
10-24
10-32
1/4-20
1/4-28
5/16-18
5/16-24
3/8-16
3/8-24
7/16-14
7/16-20
1/2-13
1/2-20
9/16-12
9/16-18
5/8-11
5/8-18
3/4-10
3/4-16
7/8-9
7/8-14
1-8
1-14
19*
20*
27*
31*
66*
76*
11
12
20
23
32
36
35
40
55
60
75
85
130
150
125
140
190
210
14*
15*
21*
23*
50*
56*
9
9
15
17
24
27
35
40
55
60
75
85
130
150
125
140
190
210
30*
31*
43*
49*
9
10
17
19
30
35
50
55
75
90
110
120
150
180
260
300
430
470
640
710
22*
23*
32*
36*
75*
86*
13
14
23
25
35
40
55
65
80
90
110
130
200
220
320
360
480
530
Metric Course
Thread
Grade 8.8
M6-1
24M8-1.25
M10-1.5
M12-1.75
M14-2
M16-2
8
19
37.5
65
103.5
158.5
Dry
Grade 10.9
Lubed
Dry
6
14
28
48
76.5
117.5
11
27
53
91.5
145.5
223.5
Dry
Lubed
41*
43*
60*
68*
12
14
25
25
45
50
70
80
110
120
150
170
220
240
380
420
600
660
900
1000
31*
32*
45*
51*
9
10
18
20
35
35
55
60
80
90
110
130
170
180
280
320
460
500
680
740
Grade 12.9
Lubed
Dry
Lubed
7
20
39
67.5
108
165.5
13.5
32.5
64
111.5
176.5
271
10*
24*
47
82
131
200
* All torque values are in lb-ft except those marked with an * which are in lb-in.
For metric torque value (Nm) muiltiply lb-ft x 1.355 or lb-in value x 0.113.
PRINTED IN U.S.A.
177
908459/AP0603
GEHL Company 143 Water Street, P.O. Box 179, West Bend, WI 53095-0179 U.S.A
908459/AP0503
©2003
Gehl Company All rights reserved.
PRINTED IN U.S.A.

552/553 Dynalift - Hawkins Equipment

Transcription

Similar documents

RS6-42 RS8-42/44 RS10-44/55 RS12-42 Parts

Telescopic Handler - Hawkins Equipment

883 - Hawkins Equipment

3640E/3840E/4240E Parts Manual

PDF Catalogue