UPACO Adhesives

.UPACO Adhesives
WORTHEN INDUSTRIES, INC.
4105 Castlewood Road
Richmond, VA 23234
PHONE (804) 275-9231
(800) 446-9984
FAX
(804) 743-8366
UPACO Adhesives
MATERIAL
PRODUCT NAME:
PRODUCT CODE:
PRODUCT USE:
SAFETY
DATA SHEET
WATER BASE ADHESIVE
HMIS CODES: HEALTH
FABOND 886 C (COAGULANT)
FLAMMABILITY
REACTIVITY
ACTIVATOR
FOR FABOND 886
PROTECTION
TWO-PART
SYSTEM
SECTION I
MANUFACTURER'S NAME:
ADDRESS:
EMERGENCY PHONE:
INFORMATION PHONE:
NAME OF PREPARER:
DATE REVISED:
REASON REVISED:
=================
MANUFACTURER
WORTHEN
INDUSTRIES
4105 CASTLEWOOD
ROAD,
804-275-9231
804-275-9231
STEVEN E. ADAMS
JULY 17, 2002
UPDATED
SECTION II - HAZARDOUS
1
o
o
SCALE:
4=EXTREME
3=HIGH
2=MODERATE
l=SLIGHT
O=INSIGNIFICANT
B=SAFETY GLASSES,
GLOVES
B
IDENTIFICATION
RICHMOND,
VA
23234
INGREDIENTS ======================
THIS MATERIAL SAFETY DATA SHEET IS PREPARED TO COMPLY WITH THE UNITED STATES OCCUPATIONAL
SAFETY AND HEALTH ADMINISTRATION (OSHA) HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200) .
UNLISTED INGREDIENTS ARE NOT HAZARDOUS PER THE OSHA STANDARD.
OCCUPATIONAL EXPOSURE LIMITS
HAZARDOUS
CALCIUM
COMPONENT(S)
CHLORIDE
WEIGHT/PERCENT
10.0%
OSHA
N/A
PEL
ACGIH
TLV
N/A
Adhesives and Coatings for Industry Since 1866
CAS #
010043-52-4
MATERIAL
886
FABOND
=========
C
SAFETY
DATA SHEET
III
-
PHYSICAL
/
CHEMICAL CHARACTERISTICS
BOILING RANGE:
NO DATA
WEIGHT PER GALLON (LB.):
8.9
VAPOR DENSITY:
NOT DETERMINED
EVAPORATION RATE: NOT DETERMINED
SOLUBILITY IN WATER:
NOT
SOLUBLE
APPEARANCE AND ODOR:
WHITE,
OPAQUE
FREEZING POINT:
32°F
pH:
ALKALINE
COEFFICIENT OF WATER/OIL DIST.:
ODOR THRESHOLD: NOT TESTED
SECTION
FLASH POINT:
NO
SPECIAL
AETER
IV
IN AIR
MEDIA:
FlREFIGHTING
APPARATUS
FOAM,
C02,
4
SLIGHT
===============
ODOR.
TESTED
HAZARD DATA
==================
LOWER:
DRY
NO
UPPER:
DATA
NO
DATA
CHEMICAL
PROCEDURES:
DRY POLYMER AND ADDITIVES
COULD BURN.
FuLL
PROTECTIVE
CLOTHING
AND
SHOULD BE WORN.
AND EXPLOSION
HAZARDS:
HAZARDS ARE KNOWN.
HAZARDOUS COMBUSTION PRODUCTS:
THE FOLLOWING CHEMICALS:
==================
AFTER
HYDROGEN CHLORIDE,
SECTION V
WATER HAS EVAPORATED,
LOWERING pH WHICH MAY CAUSE PRECIPITATION
HAZARDOUS DECOMPOSITION
EVAPORATE AND DECOMPOSITION
HAZARDOUS POLYMERIZATION:
REACTIVITY
MAY GENERATE
DATA
==========================
COLD
AVOID
STRONG
OXIDIZING
AGENTS
AND
ACIDS,
OR COAGULATION.
OR BYPRODUCTS:
MAY GENERATE
WILL
DECOMPOSITION
CARBON MONOXIDE
STABILITY:
STABLE
CONDITIONS TO AVOID:
EXTREME
HEAT
OR
INCOMPATIBILITY
(MATERIALS
TO AVOID):
WILL
WITH
EXPLOSION
BY VOLUME -
UNUSUAL FIRE AND EXPLOSION
No UNUSUAL FIRE
LIQUID
NOT
FIRE ~
WATER HAS EVAPORATED,
BREATHING
OF
DATA
FI..AMMABLELIMITS
EXTINGUISHING
2
(COAGULANT)
SECTION
==========
PAGE
NOT
NOT
IRRITATING
OCCUR
DETERMINED,
VAPORS,
CO,
AT
CO
HIGH
2
TEMPERATURES
HYDROGEN CHLORIDE.
WATER
MATERIAL SAFETY DATA SHEET
886
FABOND
C
=========================
INHALATION
SECTION VI
HEALTH RISKS
VAPORS FOR PROLONGED PERIODS,
SKIN
4
OF
AND
SYMPTOMS OF
EXPOSURE:
INHALATION:
TO INDIVIDUALS
AVOID
BREATHING
WITH SENSITIVE
AND SYMPTOMS OF EXPOSURE:
EYES:
AIRWAYS.
AVOID
CONTACT
VAPORS MAY CAUSE EYE IRRITATION.
ABSORPTION
REPEATED
3
==============
HEALTH HAZARD DATA
VAPORS MAY CAUSE IRRITATION
SKIN AND EYE CONTACT HEALTH RISKS
WITH EYES,
PAGE
(COAGULANT)
SKIN
HEALTH
CONTACT
RISKS
MAY CAUSE
AND
SYMPTOMS OF
IRRITATION.
EXPOSURE:
PRE-EXISTING
SKIN
SKIN:
PROBLEMS
PROLONGED
MAY BE
OR
AGGRAVATED BY
PROLONGED CONTACT.
INGESTION
HEALTH RISKS
AND SYMPTOMS OF EXPOSURE:
HEALTH HAZARDS (ACUTE AND CHRONIC):
CARCINOGENICITY:
NTP?
MEDICAL CONDITIONS
ASTHMATICS
OF CLEAN,
GIVE
FIRST
INGESTION:
==============
STEPS
SPILL
PROCEDURES:
RESPIRATION.
IN
AN
15
SECTION VII
ENCLOSED
ABSORB WITH INERT
WASTE DISPOSAL:
-
A PHYSICI.}lli!
MINUTES.
SKIN:
IS
VENTILATE.
PLACE
DISPOSE
PRE-EXISTING
Do
IN CLOSED,
OF AS LIQUID
REMOVE
HOS PI TAL •
WASH THE AFFECTED
REFER
PRECAUTIONS
CASE MATERIAl.
AREA,
MATERIAL.
KNOWN.
OSHA REGULATED? NO
INHALATION:
CALL
Do NOT INDUCE VOMITING.
TO BE TAKEN IN
IS
INFORMATION
SKIN
PROBLEMS,
VAPORS.
AID
ARTIFICIAL
No
ABOVE.
GENERALLY AGGRAVATED BY EXPOSURE:
COLD WATER FOR AT LEAST
AND WATER.
LISTED
!ARC MONOGRAPHS? NO
MAY REACT TO AIRBORNE
EMERGENCY AND
BREATHING,
NO
AS
INGESTION:
TO HOSPITAL
TO
FRESH
EYES:
AIR.
FLUSH
RELEASED OR SPILLED:
FLUSH
INTO
LABELED CONTAINER
OR SOLID
PUBLIC
NOT
PLENTY
AREA WITH PLENTY OF SOAP
OR PHYSICIAN
IMMEDIATELY.
FOR SAFE HANDLING AND USE
NOT
I F
WITH
========
CONTAIN
SEWER
SPILL.
OR WATER
IF
SYSTEM.
FOR DISPOSAL.
WASTE IN ACCORDANCE WITH ALL LOCAL,
STATE AND
FEDERAL REGULATIONS.
PRECAUTIONS
TO BE TAKEN IN
HANDLING AND STORING:
REVIEW
EMERGENCY AND FIRST
AID
PROCEDURES BEFORE HANDLING.
OTHER PRECAUTIONS:
USE
PRODUCT BETWEEN 50
-
UP BEFORE,
DRINKING
EATING,
90°F
(10
IN
WELL
-
32°C).
OR SMOKING.
VENTILATED
AREA.
AVOID
WASH THOROUGHLY AFTER
SKIN
AND
HANDLING
EYE
CONTACT.
PRODUCT.
STORE
ALWAYS WASH
MATERIAL
886
FABOND
C
====================
RESPIRATORY
SAFETY
DATA SHEET
4
PAGE
4
OF
(COAGULANT)
SECTION VIII
PROTECTION:
OR VAPOR EXPOSURE
EXCEEDS
WITH MANUFACTURER'S
VENTILATION:
WEAR AN NIOH/MSHA
THE LIMITS
LIMITATIONS
LOCAL
CONTROL MEASURES
LISTED
AND OSHA
EXHAUST
IF
IN
APPROVED
SECTION
I I •
29
STANDARD
USED IN A CONFINED
CFR
===================
RESPIRATOR
OR SCBA,
RESPIRATOR
WHENEVER MIST
USE MUST BE IN ACCORDANCE
1910. 134 .
AREA.
MECHANICAL
VENTILATION
REQUIRED
FOR
SPILLING
OR
LARGE VOLUME USE.
PROTECTIVE GLOVES:
EYE PROTECTION:
ALWAYS USE SPLASH
OTHER PROTECTIVE
SPLASHING
IS
CLOTHING
PRACTICES:
AREA.
AVOID
SWALLOW OR INGEST.
OR EQUIPMENT:
TOXIC SUBSTANCES
SARA TITLE
III:
REPORT;rNG
REAUTHORIZATION
CONTACT
fuLL
HANDLE CHEMICALS
AND
WASH THOROUGHLY AFTER
SECTION
CONTROL ACT
INVENTORY AND THEREFORE
THE
GLOVES.
GOGGLES WHERE SPILLING
ALWAYS
EYE
====================
TO
PROTECTIVE
OR SPLASHING
BODY COVERING
MAY OCCUR.
CLOTHES
IF
LIKELY.
WORK/HYGIENIC
VENTILATED
WATER RESISTANT
313:
SECTION
ACT
OF
1986
OF
(SARA)
ALL
WITH THIS
THIS
AND
CARE.
TO
OPEN
SKIN.
NOT
IN
DRINK,
WELL
TASTE,
PRODUCT.
COMPONENTS OF THIS
==============
PRODUCT ARE ON THE PUBLIC
LEGISLATION.
PRODUCT CONTAINS
313
40 CFR
AND HANDLE
Do
REGULATORY INFORMATION
(TSCA):
SECTION
WITH
EXPOSURE
HANDLING THIS
IX
ARE IN COMPLIANCE
REQUIREMENTS
PROLONGED
OF
TITLE
PART
372
THE FOLLOWING TOXIC
I I I
OF
THE
CHEMICALS
SUPERFUND
AT OR ABOVE DE MINIMUS
SUBJECT
AMENDMENTS
AND
AMOUNTS.
NONE
=========================
DISCLAIMER:
OUR REFERENCES
To
THE BEST
AND SUPPLIERS.
SECTION X
OF OUR KNOWLEDGE,
DISCLAIMER
THE INFORMATION
======================
HEREIN
IS
ACCURATE AS
PROVIDED
BY