Yorktown Refractory Log Set

Transcription

INSTALLATION INSTRUCTIONS
AND OWNER'S MANUAL
YORKTOWN
LOG SET FOR UNVENTED
GAS LOG HEATER
OR
VENTED DECORATIVE APPLIANCE
MODELS
ALS-18YK-1
ALS-24YK-2
ALS-30YK-2
GAS-FIRED
LS-24YK-2 Shown
Installer:
Leave this manual with the appliance.
Consumer: Retain this manual for future reference.
WARNING: If the information in these instructions
DUHQRWIROORZHGH[DFWO\D¿UHRUH[SORVLRQPD\UHsult causing property damage, personal injury or
loss of life.
² 'RQRWVWRUHRUXVHJDVROLQHRURWKHUÀDPPDEOH
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
'RQRWWU\WROLJKWDQ\DSSOLDQFH
'R QRW WRXFK DQ\ HOHFWULFDO VZLWFK GR QRW
use any phone in your building.
,PPHGLDWHO\ FDOO \RXU JDV VXSSOLHU IURP D
neighbor’s phone. Follow the gas supplier’s
instructions.
,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH
¿UHGHSDUWPHQW
— Installation and service must be performed by a
TXDOL¿HGLQVWDOOHUVHUYLFHDJHQF\RUWKHJDVVXSplier.
Log sets comply with ANSI Z21.11.2 Unvented Heaters
and also comply with ANSI Z21.60 Decorative Vented
Appliances for Solid Fuel Burning Fireplaces. State or
local codes may only allow operation of log sets in a
YHQWHGFRQ¿JXUDWLRQ&KHFN\RXUVWDWHRUORFDOFRGHV
WARNING: If not installed, operated and maintained
in accordance with the manufacturer's instructions,
this product could expose you to substances in fuel
or from fuel combustion which can cause death or
serious illness.
7KH 45 &RGH EHORZ SURYLGHV D OLQN WR RXU KHOSIXO
“how-to” video. To get started, scan the code with your
smart phone or tablet.
Page 1
TABLE OF CONTENTS
Section
Page
Important Installation Guidelines .................................................................................................... 3
General Information ........................................................................................................................ 3
Requirements for Canada .............................................................................................................. 4
/RJ,GHQWL¿FDWLRQ/6<. ............................................................................................................. 5
/RJ3ODFHPHQW/6<. ...........................................................................................................6-12
/RJ,GHQWL¿FDWLRQ/6<. ........................................................................................................... 13
Log Placement LS-24YK .........................................................................................................14-21
/RJ,GHQWL¿FDWLRQ/6<. ........................................................................................................... 22
Log Placement LS-30YK .........................................................................................................23-31
(PEHU3ODFHPHQW/6<.3KRWRV ............................................................................................. 32
Ember Placement LS-24YK Photos ............................................................................................. 33
Ember Placement LS-30YK Photos ............................................................................................. 34
Master Parts Distributor List ......................................................................................................... 35
How to Order Repair Parts ........................................................................................................... 35
Parts Lists and Parts Views .......................................................................................................... 36
Page 2
28190-2-1015
IMPORTANT INSTALLATION GUIDELINES
Proper Log Placement
Log placement is critical to proper burner performance. Logs must
be correctly positioned onto the burner. The photos in this manual
show the proper pinned position for logs on this set. Owners need
to be shown proper log placement and instructed not to move the
logs.
/RJVPXVW¿W¿UPO\RQWRWKHEXUQHUZKHQSRVLWLRQHGDVVKRZQLQ
the photos. Malformed logs or logs with sloppy pin holes must be
replaced.
3URSHU3ODFHPHQWRI5RFN:RRODQG'HFRUDWLYH/DYD5RFN
Rock wool can be added to burners for a glowing ember effect. It
must be positioned only on the front portion of the burner. The photos
in this manual show the proper placement of rock wool.
Decorative lava rock or small wood pieces should never be placed
RQWKHEXUQHU7KHVHLWHPVDUHRQO\IRUSODFHPHQWRQWKHÀRRURI
WKH¿UHSODFHRU¿UHER[
3URSHU3ULPDU\$LUÀRZLQWR%XUQHU
)RU SURSHU EXUQHU RSHUDWLRQ DQG ÀDPH DSSHDUDQFH WKH ÀRZ RI
SULPDU\DLULQWRWKHYHQWXULWXEHORFDWHGRQWKHUHDURIWKHEXUQHU
PXVWQRWEHUHGXFHG7KLVÀRZRIDLULVUHGXFHGLIGLUWOLQWRURWKHU
obstructions build-up around or inside the venturi. Any obstruction
LQWKHYHQWXULWXEHDUHDPXVWEHUHPRYHG7KHÀRZRIDLULQWRWKH
YHQWXULLVDOVRUHGXFHGLIWKHJDVRUL¿FHLVQ¶WFHQWHUHGLQWKHYHQWXUL
inlet and/or is not aligned with the venturi. Any misalignment of the
EXUQHURUL¿FHPD\EHFRUUHFWHGE\EHQGLQJWKHVKXWWHUFDSKROGLQJ
WKHRUL¿FHWRWKHLQOHWRIWKHYHQWXULWXEH
Ceiling Fans, Portable Fans or Logs Installed Near Cold Air
Returns
&HLOLQJ IDQV RU RVFLOODWLQJ ÀRRU W\SH IDQV QHHG WR EH PRQLWRUHG
during the operation of vent-free logs. If the air blows directly into
WKHÀDPHFDXVLQJLWWRLPSLQJHRQWKHORJVHWRU¿UHER[LWVKRXOGEH
turned off or redirected. Ceiling fans could be reversed to possibly
HOLPLQDWHÀDPHLPSLQJHPHQWDQGWKHÀRRUIDQFRXOGEHUHGLUHFWHG
8SRQLQVWDOODWLRQEHDZDUHRIDQ\FROGDLUUHWXUQVRUYHQWVLQWKH
SUR[LPLW\RIWKHORJVHW$Q\GUDIWFUHDWHGDURXQGDYHQWIUHHORJ
VHWFDQFDXVHWKHÀDPHWRLPSLQJHRQWKHORJDQGFUHDWHDVRRWLQJ
situation.
WARNING: 'R QRW DOORZ IDQV WR EORZ GLUHFWO\ LQWR WKH ¿UHSODFH
$YRLGDQ\GUDIWVWKDWDOWHUEXUQHUÀDPHSDWWHUQV
WARNING: 'RQRWXVHDEORZHULQVHUWKHDWH[FKDQJHULQVHUWRU
other accessory not approved for use with this heater.
Candles
Avoid the use of scented or decorative candles while the log set is in
operation. Candles produce a residue in the air that creates a soot like
VXEVWDQFH%XUQLQJFDQGOHVZKLOHWKHORJVHWLVRSHUDWLQJPDJQL¿HV
WKHSUREOHP,WVKRXOGEHQRWHGWKDWFDQGOHVLQJHQHUDOSURGXFH
soot. The amount of time burned and the quantity of candles burned
will determine the amount of soot produced and deposited.
0DNH2ZQHUV$ZDUHRI3URSHU/RJ6HW2SHUDWLRQ
Properly installed and properly maintained log sets do not deposit
VRRWRQWKHORJV,IXVHUVVHHVRRWDSSHDURQDORJFDOOIRUVHUYLFH
Do not continue to operate the log set.
6XQNHQ)LUHSODFH
,ILQVWDOOLQJWKLVXQLWLQWRDVXQNHQ¿UHSODFH\RXPXVWUDLVHWKHÀRRU
WRLQVXUHDGHTXDWHDLUÀRZDQGJXDUGDJDLQVWVRRWLQJ5DLVH¿UHSODFH
ÀRRUXVLQJDQRQFRPEXVWLEOHPDWHULDOZKLFKLVVHFXUH
Glass Doors
Make sure that glass doors are open during all operations of the
logset. The opening of the glass door frame should be the dimension
XVHGIRUWKHPLQLPXPIURQWRSHQLQJRIWKH¿UHER[
Wood Burning Fireplaces
7KHLQWHULRURIWKH¿UHER[DQGWKHFKLPQH\VKRXOGEHFOHDQHGDQG
free of all creosote before installing a gas burning log set. Creosote
will soften when heated and can drop on the logset causing odors
and possibly sooting.
WARNING:%HIRUHLQVWDOOLQJLQDVROLGIXHOEXUQLQJ¿UHSODFHWKH
FKLPQH\ÀXHDQG¿UHER[PXVWEHFOHDQHGRIVRRWFUHRVRWHDVKHV
DQGORRVHSDLQWE\DTXDOL¿HGFKLPQH\FOHDQHU
GENERAL INFORMATION
4XDOL¿HG,QVWDOOLQJ$JHQF\
,QVWDOODWLRQ DQG UHSODFHPHQW RI JDV SLSLQJ JDV XWLOL]DWLRQ
equipment or accessories and repair and servicing of equipPHQWVKDOOEHSHUIRUPHGRQO\E\DTXDOL¿HGDJHQF\7KHWHUP
TXDOL¿HGDJHQF\PHDQVDQ\LQGLYLGXDO¿UPFRUSRUDWLRQ
or company that either in person or through a representaWLYHLVHQJDJHGLQDQGLVUHVSRQVLEOHIRUDWKHLQVWDOODWLRQ
WHVWLQJRUUHSODFHPHQWRIJDVSLSLQJRUEWKHFRQQHFWLRQ
LQVWDOODWLRQWHVWLQJUHSDLURUVHUYLFLQJRIHTXLSPHQWWKDWLV
H[SHULHQFHGLQVXFKZRUNWKDWLVIDPLOLDUZLWKDOOSUHFDXWLRQV
UHTXLUHGDQGWKDWKDVFRPSOLHGZLWKDOOWKHUHTXLUHPHQWVRI
the authority having jurisdiction.
State of Massachusetts: The installation must be made
E\DOLFHQVHGSOXPEHURUJDV¿WWHULQWKH&RPPRQZHDOWK
of Massachusetts.
6HOOHUVRIXQYHQWHGSURSDQHRUQDWXUDOJDV¿UHGVXSSOHmental room heaters shall provide to each purchaser a
copy of 527 CMR 30 upon sale of the unit.
,Q WKH 6WDWH RI 0DVVDFKXVHWWV XQYHQWHG SURSDQH DQG
QDWXUDOJDV¿UHGVSDFHKHDWHUVVKDOOEHSURKLELWHGLQEHGrooms and bathrooms.
7KHLQVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHVRULQWKHDEVHQFH
RI ORFDO FRGHV ZLWK WKH National Fuel Gas Code, ANSI Z223.1/
NFPA54.*
*Available from the American National Standards Institute, Inc. 11 West
42nd St., New York, N.Y. 10018.
28190-2-1015
Page 3
REQUIREMENTS FOR CANADA
This unit cannot EH LQVWDOOHG LQ D 819(17(' DSSOLFDWLRQ WKLV
unit can only be installed as a VENTED application with these
requirements.

IMPORTANT SAFETY INFORMATION
This unit complies with ANSI Z21.60and CGA 2.26 Decorative
Gas Appliances For Installation In Solid Fuel Burning Fireplaces.
'RQRWEXUQZRRGRUVROLGIXHOVLQD¿UHSODFHZKHUHDGHFRUDWLYH
gas log set is installed. This appliance is for installation only in
DVROLGIXHOEXUQLQJ¿UHSODFHPDVRQU\¿UHSODFHRUPDQXIDFWXUHG
¿UHSODFH
Warning: $Q\PRGL¿FDWLRQWRWKLVJDVORJVHWRUWRFRQWUROVFDQ
be dangerous. Improper installation or use of the gas log set can
FDXVHVHULRXVLQMXU\RUGHDWKIURP¿UHEXUQVH[SORVLRQRUFDUERQ
PRQR[LGHSRLVRQLQJ
3OHDVHIROORZDOOORFDOFRGHVUHJDUGLQJLQVWDOODWLRQFRPEXVtion and ventilation air or in the absence of local codes follow
WKH1DWLRQDO)XHO*DV&RGH$16,=86LQVWDOODWLRQRU
&$1&*$%,QVWDOODWLRQ&RGH&DQDGDLQVWDOODWLRQ
3URSHULQVWDOODWLRQEXUQHUSDQORFDWLRQDQGORJSODFHPHQWLV
important to achieve optimum look and performance of your
gas log set. The logs have been designed for easy location
and placement on the grate and must be followed for proper
operation.
3. Do not operate this log set with glass doors in the closed posiWLRQ$¿UHSODFHVFUHHQPXVWEHLQSODFHZKHQWKHORJVHWLV
burning. Adequate combustion air must be provided for proper
YHQWLQJ$OOÀDPHVVKRXOGJRXSDQGRXWWKHWRSRIWKH¿UHER[
LQWRWKHÀXHYHQW,IDQ\ÀDPHVÀRDWRUFXUOIRUZDUGLQWRWKH
URRPGRQRWRSHUDWHDSSOLDQFH&KHFNIRUDQRSHQÀXHDQG
adequate combustion air into the room. A damper clamp must
EHLQVWDOOHGRQWKH¿UHER[GDPSHUWRPDLQWDLQDQRSHQÀXH
YHQWFRQGLWLRQ6HH¿UHSODFHLQVWUXFWLRQVPDQXDOIRULQVWDOOLQJ
damper clamp.
4. Young children must be carefully supervised when they are in
the same room as the gas log while in operation. Do not place
VWRFNLQJVFORWKLQJRUDQ\ÀDPPDEOHPDWHULDODERYHRUQHDU
WKH¿UHSODFH
5. Do not substitute or use materials other than those supplied
for use with the log set.
6. Also refer to IMPORTANT SAFETY INFORMATION on page
3 of this manual

,QVWDOODWLRQDQGUHSDLUVKRXOGEHGRQHE\DTXDOL¿HGVHUYLFH
person. The appliance should be inspected before use and
DWOHDVWDQQXDOO\E\DTXDOL¿HGVHUYLFHSHUVRQ0RUHIUHTXHQW
FOHDQLQJPD\EHUHTXLUHGGXHWRH[FHVVLYHOLQWIURPFDUSHWLQJ
EHGGLQJPDWHULDOVHWF,WLVLPSHUDWLYHWKDWFRQWUROFRPSDUWPHQWVEXUQHUVDQGFLUFXODWLQJDLUSDVVDJHZD\VRIWKHDSSOLance be kept clean.
Do notSXWDQ\WKLQJDURXQGWKH¿UHSODFHWKDWZLOOREVWUXFWWKH
ÀRZRIYHQWLODWLRQDLU
Do keep the appliance area clear and free from combustible
PDWHULDOJDVROLQHDQGRWKHUÀDPPDEOHYDSRUVDQGOLTXLGV
$ \HDUO\ H[DPLQDWLRQ DQG FOHDQLQJ RI WKH YHQWLQJ V\VWHP RI
WKHVROLGIXHOEXUQLQJ¿UHSODFHPXVWEHSHUIRUPHGE\DTXDOL¿HGDJHQF\
Do make a periodic visual check of pilot and burners. Clean
and replace damaged parts.
Do not use this appliance if any part has been under water.
,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQWRLQVSHFWWKH
appliance and to replace any part of the control system and
any gas control which has been under water.
1HYHUEXUQVROLGIXHOVLQ¿UHSODFHZKHUHDJDVORJVHWLVLQstalled.
7KLVXQLWFRPSOLHVZLWK$16,='HFRUDWLYH9HQWHG$SSOLances for Solid Fuel Burning Fireplaces. State or local codes
PD\RQO\DOORZRSHUDWLRQRIWKLVDSSOLDQFHLQDYHQWHGFRQ¿JXration. Check your state or local codes.
:$51,1* '2 127 23(5$7( 7+,6 *$6 /2* 6(7 :,7+
GLASS DOORS CLOSED

&ORWKLQJRURWKHUÀDPPDEOHPDWHULDOVKRXOGQRWEHSODFHGRQ
or near the appliance.
'RQRWSODFHWUDVKRURWKHUDUWLFOHVRQWKHORJVHWGXULQJRSeration.
'XULQJPDQXIDFWXULQJIDEULFDWLQJDQGVKLSSLQJYDULRXVFRPSRQHQWVRIWKLVDSSOLDQFHDUHWUHDWHGZLWKFHUWDLQRLOV¿OPVRU
bonding agents. These bonding agents are not harmful but
may produce annoying smoke and smells as they are burned
off during initial operation of the appliance. This is a normal
temporary occurrence. A window should be opened during the
initial bake out period.
.HHSEXUQHUDQGFRQWUROFRPSDUWPHQWFOHDQ
WARNING: %HIRUHLQVWDOOLQJLQDVROLGIXHOEXUQLQJ¿UHSODFH
WKHFKLPQH\ÀXHDQG¿UHER[PXVWEHFOHDQHGRIVRRWFUHRVRWHDVKHVDQGORRVHSDLQWE\DTXDOL¿HGFKLPQH\FOHDQHU
Page 4
28190-2-1015
ALS-18YK LOG IDENTIFICATION
Log
Description
Part Number
Log A
R10257
Log B
5
Log C
R10260
Log D
R10259
Log F
R10262
Front View
Top View
Note: ALS-18YK does not contain a Log E and is not needed for assembly.
28190-2-1015
Page 5
LOG PLACEMENT ALS-18YK
%HIRUH\RXEHJLQ'RQRWKDQGOHWKHVHORJVZLWK\RXUEDUHKDQGV
$OZD\VZHDUJORYHVWRSUHYHQWVNLQLUULWDWLRQ$IWHUKDQGOLQJORJV
wash your hands gently with soap and water.
All Logs
The positioning of the logs is critical to the safe and clean operation
of this heater. Sooting and other problems may result if the logs are
QRWSURSHUO\DQG¿UPO\SRVLWLRQHGLQWKHDSSOLDQFH
WARNING
This appliance is equipped for (natural or propane) gas. Field
conversion is not permitted.
Ember Placement
Apply loose material (glowing embers) per appropriate Installation
Instructions and Owner's Manual. Replacement of loose material
(glowing embers) must be purchased from Empire Comfort SysWHPV,QF$SSOLFDWLRQRIH[FHVVORRVHPDWHULDOJORZLQJHPEHUV
may adversely affect performance of the heater. WARNING: All
previously applied loose material must be removed prior to reapplication.
Replacement Loose Material
(glowing embers)
Part Number
$/6<.
15999
Platinum Bright Embers
PE-20-1
WARNING
Failure to position the parts in accordance with this diagram or
IDLOXUHWRXVHRQO\SDUWVVSHFL¿FDOO\DSSURYHGZLWKWKLVDSSOLDQFH
may result in property damage or personal injury.
C
F
Note: A single layer of embers is to be used when applying Platinum
Bright Embers (alone or in combination with production embers)
to the burner.
Attention: Do not use Figure 1 to order replacement logs. Refer to
Page 35 Parts List and Parts View to order logs for your appropriate
model number.
E
B
D
A
Log Placement
LS-18YK Logs
Figure 1
Note: LS-18YK does not contain a Log E and is not needed
for assembly.
Scan this code to see the log assembly video.
Page 6
28190-2-1015
1. Place Log C onto right rear pin on rear log support as shown below.
28190-2-1015
Page 7
2. Place Log D onto left rear pin on rear log support as shown below.
3DJH
28190-2-1015
3. Place Log A onto two front left burner pins as shown below.
28190-2-1015
Page 9
4. Place Log B onto two front right burner pins as shown below.
Page 10
28190-2-1015
5. Insert boss on Log F into recess on right side of Log C and Log B as shown below.
28190-2-1015
Page 11
6. Log placement is completed.
Page 12
28190-2-1015
Log
Description
Part Number
Log A
R10264
Log B
R10265
Log C
R10267
Log D
R10266
Log E
5
Log F
R10262
28190-2-1015
Front View
Top View
Page 13
All Logs
WARNING
Ember Placement
(glowing embers)
Part Number
ALS-24YK
15970
PE-20-1
WARNING
C
F
to the burner.
model number.
E
B
D
A
Log Placement
LS-24YK Logs
Figure 2
Page 14
28190-2-1015
1. Place Log C onto right rear pin on rear log support as shown below.
28190-2-1015
Page 15
2. Place Log D onto left rear pin on rear log support as shown below.
Page 16
28190-2-1015
3. Place Log A onto two front left burner pins as shown below.
28190-2-1015
Page 17
4. Place Log B onto two front right burner pins as shown below.
3DJH
28190-2-1015
5. Insert boss on Log F into recess on right side of Log C and Log B. See image below.
28190-2-1015
Page 19
6. Insert boss on Log E into recess on Log D and resting on Log A. See image below.
Page 20
28190-2-1015
7. Log placement is completed.
28190-2-1015
Page 21
Log
Description
Part Number
Log A
R10271
Log B1
R10261
Log B2
R10272
Log C
R10274
Log D
R10273
Log E
5
Log F
R10262
Page 22
Front View
Top View
28190-2-1015
All Logs
WARNING
Ember Placement
(glowing embers)
Part Number
ALS-30YK
15970
PE-20-1
WARNING
F
C
E
B2
to the burner.
model number.
D
B1
A
Log Placement
LS-30YK Logs
Figure 3
28190-2-1015
Page 23
1. Place Log C onto right rear burner pin as shown below.
Page 24
28190-2-1015
2. Place Log D onto left rear burner pin as shown below.
28190-2-1015
Page 25
3. Place Log B1 onto two front right burner pins as shown below.
Page 26
28190-2-1015
4. Place Log A onto two left front burner pins as shown below.
28190-2-1015
Page 27
5. Place Log B2 onto notch on Log B1. Groove on bottom of Log B2 will rest on Front Log A as shown below.
3DJH
28190-2-1015
6. Insert boss on Log F into recess on right side of Log C and Log B. See image below.
28190-2-1015
Page 29
7. Insert boss on Log E into recess on Log D. Rest Log E onto Log A as shown below.
Page 30
28190-2-1015
/RJSODFHPHQWLVFRPSOHWH
28190-2-1015
Page 31
Page 32
Photo 3
Photo 1
Photo 4
Do not cover any large front ports with
loose material(glowing embers).
Do not cover any large rear ports with
Photo 2
EMBER PLACEMENT ALS-18YK PHOTOS
28190-2-1015
28190-2-1015
Photo 3
Photo 1
Photo 2
Photo 4
Do not cover any large front ports with
Do not cover any large rear ports with
(Some Logs Have Been Removed For Clarity)
Page 33
Page 34
Photo 4
Photo 3
Photo 1
Photo 2
28190-2-1015
MASTER PARTS DISTRIBUTOR LIST
7R2UGHU3DUWV8QGHU:DUUDQW\SOHDVHFRQWDFW\RXUORFDO(PSLUHGHDOHU6HHWKHGHDOHUORFDWRUDWZZZHPSLUHFRPIRUW
FRP7RSURYLGHZDUUDQW\VHUYLFH\RXUGHDOHUZLOOQHHG\RXUQDPHDQGDGGUHVVSXUFKDVHGDWHDQGVHULDOQXPEHUDQGWKH
nature of the problem with the unit.
7R2UGHU3DUWV$IWHUWKH:DUUDQW\3HULRGSOHDVHFRQWDFW\RXUGHDOHURURQHRIWKH0DVWHU3DUWV'LVWULEXWRUVOLVWHGEHORZ
7KLVOLVWFKDQJHVIURPWLPHWRWLPH)RUWKHFXUUHQWOLVWSOHDVHFOLFNRQWKH0DVWHU3DUWVEXWWRQDWZZZHPSLUHFRPIRUWFRP
Please note: Master Parts Distributors are independent businesses that stock the most commonly ordered Original EquipPHQWUHSDLUSDUWVIRU+HDWHUV*ULOOVDQG)LUHSODFHVPDQXIDFWXUHGE\(PSLUH&RPIRUW6\VWHPV,QF
Dey Distributing
1401 Willow Lake Boulevard
9DGQDLV+HLJKWV01
Victor Division of F. W. Webb Company
200 Locust Street
+DUWIRUG&7
Phone: 651-490-9191
Toll Free:
Website: www.deydistributing.com
Parts: Heater, Hearth and Grills
Phone:
Toll Free: Fax: Toll Free Fax:
Websites: www.fwwebb.com & www.victormfg.com
East Coast Energy Products
10 East Route 36
:HVW/RQJ%UDQFK1-
Phone: Toll Free:
Fax: Website: www.eastcoastenergy.com
HOW TO ORDER REPAIR PARTS
Parts Not Under Warranty
3DUWVFDQEHRUGHUHGWKURXJK\RXU6HUYLFH3HUVRQ'HDOHURUD0DVWHU3DUWV'LVWULEXWRU6HHWKLVSDJHIRUWKH0DVWHU3DUWV'LVWULEXWRUVOLVW)RUEHVWUHVXOWVWKHservice person or dealer should order parts through the distributor. Parts can be shipped directly to the
service person/dealer.
Warranty Parts
Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for
warranty parts.
$OOSDUWVOLVWHGLQWKH3DUWV/LVWKDYHD3DUW1XPEHU:KHQRUGHULQJSDUWV¿UVWREWDLQWKH0RGHO1XPEHUDQG6HULDO1XPEHUIURPWKH
name plate on your equipment. Then determine the Part Number (notWKH,QGH[1XPEHUDQGWKH'HVFULSWLRQRIHDFKSDUWIURPWKHIROlowing illustration and part list. Be sure to give all this information . . .
Appliance Model Number
Part Description
Appliance Serial Number
Part Number
Type of Gas (Propane or Natural)
'RQRWRUGHUEROWVVFUHZVZDVKHUVRUQXWV7KH\DUHVWDQGDUGKDUGZDUHLWHPVDQGFDQEHSXUFKDVHGDWDQ\ORFDOKDUGZDUHVWRUH
6KLSPHQWVFRQWLQJHQWXSRQVWULNHV¿UHVDQGDOOFDXVHVEH\RQGRXUFRQWURO
28190-2-1015
Page 35
PARTS LIST & PARTS VIEW
Attention::KHQRUGHULQJSDUWVLWLVYHU\LPSRUWDQWWKDWpart number and description of part coincide.
F
E
C
E
F
D
B2
C
D
B
A
ALS-30YK-1
ALS-18YK-1
INDEX LETTER
DESCRIPTION
PART NUMBER
INDEX
LETTER
A
FRONT LEFT LOG
R10271
B1
EMBER BED LOG
R10261
B2
FRONT RIGHT LOG
R10272
C
REAR RIGHT LOG
R10274
A
FRONT LEFT LOG
R10257
FRONT RIGHT LOG
5
C
REAR RIGHT LOG
R10260
D
REAR LEFT LOG
R10259
E
TOP LEFT LOG
F
TOP CENTER LOG
N/A
R10262
ALS-24YK-1
DESCRIPTION
DESCRIPTION
PART NUMBER
B
INDEX
LETTER
B1
A
D
REAR LEFT LOG
R10273
E
TOP LEFT LOG
5
F
TOP CENTER LOG
R10262
PART NUMBER
A
FRONT LEFT LOG
R10264
B
FRONT RIGHT LOG
R10265
C
REAR RIGHT LOG
R10267
D
REAR LEFT LOG
R10266
E
TOP LEFT LOG
5
F
TOP CENTER LOG
R10262
USE ONLY MANUFACTURER'S REPLACEMENT PARTS. USE OF ANY OTHER PARTS COULD CAUSE INJURY OR DEATH.
A Registered Trademark of Empire Comfort Systems Inc.
)UHHEXUJ$YH%HOOHYLOOH,/
,I\RXKDYHDJHQHUDOTXHVWLRQDERXWRXUSURGXFWVSOHDVHHPDLOXVDW
[email protected].
,I\RXKDYHDVHUYLFHRUUHSDLUTXHVWLRQSOHDVHFRQWDFW\RXUGHDOHU
Page 36
28190-2-1015