4x4 Sprinter - Rossetts Commercials

4x4 Sprinter
Keeping you on the road and in the field!
Whether you are on the road in winter with snow and ice or trying to cross a muddy
paddock without getting stuck, the Mercedes-Benz 4x4 Sprinter has you covered.
The 4x4 Sprinter version uses a development of the existing Mercedes-Benz 4-RTS
(electronic Traction System) technology, which is functionally integrated with Adaptive
ESP offering unrivalled traction management in operation.
All 4x4 Sprinter models models use a fully developed and integrated factory assembled
driveline and are built alongside 4x2 models; they are not aftermarket conversions and
are covered by full Mercedes-Benz Warranty and supported by the Dealer Network. 4x4
vehicles work to the same production lead time as conventional models.
Although they have an increased ride height in comparison to normal models, the
ground clearance beneath the axles remains the same as a normal 4x2 vehicle. The
4x4 technology is designed to improve traction in adverse ground conditions, and is not
intended to offer severe off road capability.
Selectable 4x4 with low range
The 4x4 Sprinter model features the selectable low range transmission previously
available as option code ZG3. This enhances the traction and gradeability of the Sprinter
range even further. Building on the selectable 4x4 system the addition of a selectable
low ratio gear set increases the climbing ability of the Sprinter 4x4. Major features of the
system are as follows:
• The 4x4 system is turned on and off electro-hydraulically. Ideally the system should
be engaged or disengaged when the vehicle is stationary. It is possible to select at
vehicle speeds up to 6mph/10 kmh if conditions demand.
• The system is operated by a dashboard mounted rocker switch with integrated
indicator lights to show selection and full engagement.
• 4x4 operation is switched off automatically when the ignition is switched off.
Standard UK specification on all 4x4’s:
•
•
•
•
•
•
100 litre fuel tank KB0
Entrance grab handles on both front doors T75
Exterior mirrors without indicator repeater lamps FU5
Indicator repeater lamps in front wings L44
Rear fog lamp integrated in rear bumper instead of tail lamp cluster (Van)
Mixed use tyre (M+S - Mud + Snow - tread pattern) for optimum all round suitability
• 3-Series: Continental Vanco Winter pattern RM1
• 5-Series: Continental Vanco Winter pattern RM1
• Tyre size:
• 3-Series @ 3.5t GVW = 225/75R16 (Sales Code RG8)
• 5-Series @ 5t GVW = 205/75R16 (Sales Code RG3)
Comments relating to the 4x4 systems:
• When using alternative (aftermarket) tyres for these models please ensure that the
tyre capacity is adequate for the axle weights of the relevant vehicle.
• The axle ratio fitted to 4x4 models will be one step slower than the equivalent
standard 4x2 vehicle it is based upon (e.g a 313CDI medium has an axle ratio of
4.182, a 313CDI medium 4x4 has an axle ratio of 4.364). Optional ratios are available
depending on model.
• All 4x4 models are speed limited to maximum of 75 mph/120 kmh (where a lower
legal limit does not already apply) due to driveline configuration.
Model and engine availability
Van
3.5t/5t Medium
3.5t/5t Long
Yes
Yes
Yes
Yes
Yes
Yes
3.5t/5t Medium
3.5t/5t Long
Yes
Yes
Yes
Yes
Yes
Yes
3.5t/5t Medium
3.5t/5t Long
Yes
Yes
Yes
Yes
Yes
Yes
129HP CDI Diesel
163HP CDI Diesel
190HP CDI Diesel
Chassis Cab & Chassis Crewcab
129HP CDI Diesel
163HP CDI Diesel
190HP CDI Diesel
Traveliner TL7 and TL9
129HP CDI Diesel
163HP CDI Diesel
190HP CDI Diesel
Technical Data
Models
213CDI
313CDI
513CDI
Variants
Panel Van/Combi/Chassis with single or double cabin
Engines
4 -cylinder diesel engine
Power Output / Torque
95 kW
129 HP
305 Nm
EURO 5, 6
Transmission1
6-speed manual or 5-speed automatic
Wheel base1
Medium wheel base 3,665mm
Long wheel base 4,325mm
Rear axle drive ration1
AR1 = 3.692 / AR2 = 3.923 / AR3 = 4.182 / AR4 = 4.364 / AR5 = 4.727 / AR6 = 5.1001
Brakes
Dual circuit hydraulic brake system with vacuum booster. Disk brakes on all wheels, ESP 1.
Parking brake on all wheels. Anti-locking-brake sytem. ADAPTIVE ESP®.
Fuel capacity
100 litres
Maximum overall gross weight
1
Depends on model and variant.
216CDI
316CDI
516CDI
219CDI
319CDI
519CDI
6-cylinder diesel engine
120 kW
163 HP
360 Nm
EURO 5, 6
3,000kg / 3,500kg
140 kW
190 HP
440 Nm
EURO 5, 6
5 speed auto only
5,000kg �(Double tyres)
Contact Details
ALDERSHOT
Unit 1 Eastern Road, Aldershot, Hampshire, GU12 4TD
Tel: 01252 353400
Email: [email protected]
CRAWLEY
Unit 1 Manor Gate, Manor Royal, West Sussex, RH10 9SX
Tel: 01293 652560
Email: [email protected]
EASTBOURNE
7 Birch Road, Eastbourne, East Sussex, BN23 6PD
Tel: 01323 462500
Email: [email protected]
WORTHING
Meadow Road Industrial Estate, West Sussex, BN11 2RU
Tel: 01903 223400
Email: [email protected]
Every care has been taken in the preperation of this product brochure but no
liability can be accepted for the use of the information therein.
4x4 Sprinter July 2014
You can find us at www.rossetts.co.uk
Rossetts Commercials Mercedes-Benz
rossettscommercials
@teamrossetts